SAFETY PRECAUTIONS

SERVICE WARNING
Only qualified service technicians who are familiar with safety checks and guidelines should perform service work. Before replacing parts, disconnect power source to protect electrostatically sensitive parts. Do not attempt to modify any circuit unless so recommended by the manufacturer. When servicing the receiver, use an isolation transformer between the line cord and power receptacle.

PHOTOFACT®
INDEX
GridTrace Closed Location Caption Board 3 4 3 3 1 4 1 4 Adjustments DPCBoard Main Board MTS Board IC Functions Important Parts List Parts Information Miscellaneous

Technical Service Data

TOSHIBA
Model CF27C30 (Chassis TAC9350)

SAFETY CHECKS - FIRE AND SHOCK HAZARD

Cold Leakage Checks for Receivers with Isolated Ground
Unplug the AC cord, connect ajumper across the plug prongs, and tum the power switch on (if applicable). Use an ohmmeter to measure the resistance between the jumped AC plug and any exposed metal cabinet parts such as antenna screw heads, control shafts, or handle brackets. Exposed metal parts with a return path should measure between 1M ohms and 5.2M ohms. Parts without a return path must measure infinity.

SERVICING THE HIGH VOLTAGE AND CRT

Use EXTREME CAUTION when servicing the high voltage circuits. To discharge static high voltage, connect a 10K ohms resistor in series with a test lead between the receiver and CRT anode lead. DO NOT lift the CRT by the neck. Always wear shatterproof goggles when handling the CRT to protect eyes in case of implosion.

Hot Leakage Current Check

Plug the AC cord directly into an AC outlet. DO NOT use an isolation transformer. Use a 1500 ohms, lOW resistor in parallel with a .151J.Fcapacitor to connect between any exposed metal on the receiver and a good earth ground. (See figure Use an AC voltmeter with at least 5000 ohms volt exposed metal parts and measure voltage at each point. Voltage measurements should not exceed .75VAC, 500j.IA. Any value exceeding this limit constitutes a potential shock hazard and must be corrected. If the AC plug is not polarized, reverse the AC plug and repeat exposed metal part voltage measurement at each point.

X·RAY RADIATION AND HIGH VOLTAGE LIMITS

Be aware of the instructions and procedures covering X-ray radiation. In solid-state receivers and monitors, the CRT is the only potential source of X -rays, Keep an accurate high voltage meter available at all times. Check meter calibration periodically. Whenever servicing a receiver, check the high voltage at various brightness levels to be sure it is regulating properly. Keep high voltage at rated value, NO IDGHER. ExcesSiVenignVoitage may cause X-ray radiatl6iioffaiTlire of associated components. DO NOT depend on protection circuits to keep voltage at rated value. When troubleshooting a receiver with excessive high voltage, avoid close contact with the CRT. DO NOT operate the receiver longer than necessary. To locate the cause of excessive high voltage, use a variable AC transformer to regulate voltage. In present receivers, many electrical and mechanical components have safety related characteristics which are not detectable by visual inspection. Such components are identified by a # on both the schematic and the parts list. For SAFETY, use only equivalent replacement parts when replacing these components.

Safety Precautions
Schematics Audio Closed Caption Control ,.,,,

1
3 3 2 2 :.......... 1 1 1 1 1
,,<

GENERAL GUIDELINES
Defore returning receiver to customer. Check repaired area for poorly soldered connections, and check entire circuit board for solder splashes. Check inner board wiring for pinched wires or wires contacting any high wattage resistors. Check that all control knobs, shields, covers, grounds, and mounting hardware have been replaced. Be sure to replace all insulators and restore proper lead dress.

FerfornrafifiaiSArISTYCitr.CK

In (W)
0)

Power Supply System . : .. .. .ci.cs;cio.~ l1ec;l;ec .... ~v n', Schematic Notes Test Equipment Test Jig Hookup Troubleshooting Tuner Information

(,)

en en en
c:::c
(,)

:::J:

o ~
~AC LUSCALE VOLTMETER
N

Complete coverage for servicing a television receiver ... • Schematics • Component locations • Parts list • Troubleshooting guide

(")

(,)

LL ..J

W C

o
:i
CONNECTTO EARTHGROUND

Coverage includes these additional models and chassis:

MODEL
CF26C30 TV28C30 The listing of any available replacement part herein in no case constitutes a recommendation, warranty, or guarantee by Howard W. Sams & Company as to the quality and suitability of such replacement part. The numbers of the listed parts have been compiled from information furnished to Howard w. Sairts & Company by the manufacturers of the specific type of replacement part listed. Reproduction or use, without express permission, of editorial or pictorial content, in any manner, is prohibited. No patent liability is assumed with respect to the use of the information contained herein.

CHASSIS
TAC9360 TAC9365

©1994 by Howard W. Sams & Company 2647 Waterfront Parkway East Drive, Suite 300 Indianapolis, IN 46214-2012

Printed in the United States of America

5432

94PF02648

e
.

5: en o
81262 03335

c:::c

Page 1

SET 3335

For Supplier Address, See PHOTOFACT Annual Index

HOWARD W. SAMS & COMPANY

JUNE 1994 SET 3335

SYSTEM CONTROL SCHEMATIC

P002 75~ ANTl__j IR-9109A-K IR RECEIVER RA27 ~------------~l~O~K---~~RMT 2 .----:------;2;;;-12 SA06 FUNC SA05 SAO 1 POWER RAl02 ~ 1BOO V~~ DAS6~1-:5;---------------------------~~-----___':W;___':-S-EE-I-CM-o-2-----4:;-l .. TO ~ SEE IC501 ~l~E4~B SEE IC501 ~1~E4~c SEE IC501 ~l~E3~C

~g6
X INTt.4P47C430N-UB03 2.1V ICAOI MICROPROCESSOR X OUT ClK 1-:-:-----------------------2.BV11 23 2.3V RAll 1000 - - - -,...-"""-----t---",._-------'---'-'---,-J3 CA l l 0 100pF

~6~
rvBD/~ift~~TERr:~Vl-:l-:-l----------

,---0-- PIN lB
RA1777 PAGE 3C lOOK

DIGITAL CONTROL CO}~~ 12 ClK 3.0V :.8~l-:l:::3:--~---;iW----~-

......

RA06 1000

l l

.-..:....,.;,.;...-----, ........ -:11 ~~9v

RA76 __ ~DATA 2 2.6V BRIGHTNES,"!-:...,..4.6V 14 SEE ICM02

RAl0l 5100 5.0V(A)

KEY A 6 2.4V

RA12 DATA ~;-------------------------_,...___.:l~O~OO~~--4~~~l~O~OK___.:~~~--2.6V 12 RA15 2200 5 DMll0 155133 RA16 Oel-:l:::6-~2~20~0~----~---~'*___,r--DM100 155133 CA120 100pF

R OV15 B

SEE ICMOl PIN 6 PAGE 3C

RA74 10K

SEE IC501 PIN 36 PAGE 2C SEE IC501 ~l~E4~C

5.0V(A)

Hr-lo6--

~l~E 1~C

CONT~J 1-:1:-::5:----------BAL 1-=----0------4.5V 7 RABO T2.~ 1-:9::-6~Bv..K:..--BD_E------

SEE ICMOl PIN 10 PAGE 3C SEE ICMOl PIN 1 PAGE 3C

~i~ ~604
PAGE 3B

2SC1740S-0 QA 1 5 HORIZPULSEDET

RM100 10K

~%

BC I-l"'O--~O------RA79 10K

~i~ ~604
PAGE 3B SEE 0507 BASE PAGE 3A

I---::---~-"t_---

SEE IC301 PIN 7 PAGE2A

RAB7 82K

RN1201 QA 1 4 VERT PULSEDET .1V RAB5 10K 5.0V(A)

RA1B 10K

VD 18 4.8V

SP OFF 5.0V 25

RA251 (RA24) 1000 RAOl 680

RA25 1000

SEE IC610 PIN 11 PAGE 3B SEE OG04 BASE PAGE 3A

TUNER NOTINCLUDED IN THIS COVERAGE ROOl L____.:l~OO~O:..----------~~~-----------------_~SNER R002 RA73t--~1~0~00~-----------------------------_~60CK

1~ ruNffi

DATA

MTS 3.9V 1 2SC1740S-0 QA91 SYNC AMP

BO

2SA564 QA90 SYNCDET SEE 0141 EMITTER PAGE 2B ~~}

RA90 300

RA93 3900

PRDkc::;--------------------------------~~------~-~~-~r_------------------~-~SNER .7V 10 RA02 R~~~~2;--~~-------------~~~~

5.0V(A) CA 100

~6g

PRD/ENABlE R01003K

SEE OE05 2E

l~I

~ 5.0V(A)

QAll SEE IC501 PIN 50 PAGE2A

2SA933S AFT AMP

RN1201 QA10 AFT AtAP

RAD4 ~-~10~0~0-------------4~~~V OV13 r---~---"t-~2~8~~~~V

RA13 1000

RA130 10K

2SC1740S-0 QA 13 Sr,W::-IT."C.,..H _ _,.. .2V DB18 155176

~i~ 1~501
PAGE 2C SEE IC501 PIN 43 PAGE 2B

RE03 750 DE50 POWER TlS153FA

9.0V(A)

.J
5.0V

14

VSS

5.0V(A) Bl SEE ICGOl PIN 2 PAGE 3A

m~
+5V TO

CAll 22001'f

BM SEE 0840 PIN 4 PAGE2E RA24 1000 ---------....:.;y,;:...-;:-:-=-r-~71 HOLD 24 5.3V CA20 01 . 5.0V

SEE ICGOl PIN 3 PAGE 3A VOLTAGES TAKEN WITHSIGNAL A PHOTOFACT STANDARD NOTATION SCHEMATIC

RA08 1000
I I

4.4V 8 MODE

OSCl 2.6V 19 OSC2 2.7V 20

-,
LAO 1

WITH
Howard

GM§iiil$lW
Scme &
Co.

W.

1994

RA35 36K 5.0V(A)

I

...

I I

Lt-ii

I I

ADDmONAl CHEMATIC S NOTES, EE PAGE1 S

SET 3335

Page 2

MAIN BOARD
SAO1 POWER KS10 SA02 CH UP SA03 CH ON SAO4 VOL UP SA05 SA06 VOL ON FUNCTION

PLACEMENT CHART
SAOS

DPC BOARD
6
OA10

CLOSED CAPTION BOARD

6
lCAOl

3n2
3031

P603

POOl

40 4243

CJ

QAll

0
ICA02 1

~
R876~

rsoz lA
LAO1 OA12

OASl

CJ

UJJ
1 7
IC301 BA. BS. BP. BO. BO. BN. BM. BL. BC. Bo. BE· BF· BK·

HI
0001

OM03

0
16

ICMOl S

[QJ 14 15 OA15 OA13

16

OM04

~ 1
PMOl

"D
18 5.0V(B) S.OV(8)

ICM02

CJ CJ

OA14

OASO

0002

0862

• •
5

0601

L171[QJ L105 [QJ 54 0602 P401 IC501 27 R611

CJ
0803

0
0863

0840

»
0404

OJ

R659 ~ INPUT LEVEL

CJ

R152 ~ RF AGC 08420840

?
1

MTS BOARD
~
~~1 16 S.OV

RG53 LOW SEPARATION

ffff

I.,L,L

o
OE05 0290

X401

F~EffR

RG52 HIGH SEPARATION

I
~

08410843

o OG02
Oac03
, f""""\.__f'l:jICGOl 42

SR81

0604 (IC604)

OG04

21

22

o
c
~ m

3:

I. ••••1
X201 0271 28

MS03

R327 0865 (IC865)

o
PG02

r.......

CJ

8
6. TAKEN

T801

II

F801 5A

TUNER

II

E3 2 1

P802

OS09

10
ICSOl

23 21 22 20

I.
10

D BA BS BPBOBOBNBMBLBCBoBEBF

BK

•••••••••••

o OS08
CJ

9 OS07

0V70

OE35

R257 SUB BRIGHTNESS

-0 :::J: » en
en

~ o

~
PS03

en

CRT BOARD
o
~1 ~~ 24 25 ~ ~ RS58 RS57 BLUE GREEN BIAS BIAS

FROM COMMON TIE POINT ~

PS07

PS08

c::J
OSlO

en

o CD
(.,)

i!

0
TEST JIG HOOKUP
Function
CRT Yoke Yoke Setting Comments

0908

c::J
osos

Chek·A·Color Adapter No.

B239 D4137 YP2A Focus Tap

PC Board Plug No.

P401

Pin
7

Color
Blue Red Yellow Green

8
9 10

SET 3335

Page 1

POWER SUPPLY SCHEMATIC

,, ,

rl

C899 .22

C810 470!,F 200V

l:::,

TAKEN FROM COMMON TIE POINT,\.

,
C448+ 33# 160V ,

115V SOURCE

..
,,
20.0V SOURCE 9.0V SOURCE 5.OV SOURCE 5.0V~A) SOU CE 5.0V~B) SOU CE -28.0V SOURCE

M902 0878 04AZ36X 0891 lSS176 R872 130 11

P902 11

211V SOURCE

28.0V SOURCE

C845 .01

0840 (IC840)

L78MR05-FA VOLTAGE REG

R425 10 R874 680

PM02

BS

BS 2SA949Y PROTECT

+-----+-SEE ICAOl PIN 2

~i~

~~AOl

SFOR3G42

D862

0870

PAGE 2G

REl 1

C874 .01

ADDITIONAL SCHEMATIC NOTES, SEE PAGE 1

14 L_P-<:M,_O l---::':-:-:-,.....---:=~r--==,,_-lil!I 14 CM14 .1 5.0V(B) SOURCE

A PHOTOFACT STANDARD NOTATION SCHEMATIC

<t>

WITH
Howard

Gl;MiltiMilti
&
Co.

W. Soms

1994

Page 2

SET 3335

Page 1

SET 3335

MISCELLANEOUS ADJUSTMENTS
HIGH VOLTAGE CHECK
Tune in a picture. Set brightness, contrast, and color to. minimum. Connect a high voltage probe to. CRT anode. High voltage should read 25.0KV to. 27.0KV. High voltage should never exceed 30AKV.

TROUBLESHOOTING
POWER SUPPLY
Check FS01 and FS02. If FS01 is open, check DS01, CS01, CS02, CS03, CS10, QS01 thru QS04, and TS62. If FS02 is open, check Q404 and T461. Apply 120VAC, check for ll5V at cathode of D883. If l15V is missing, check T862, Q801 thru Q804, and Q870 .. Check for 5.0V at the cathode of DAIL If 5.0V is missing, check T840, DS40 thru DS43, Q840, and C842.1f 5.0V is present, refer to. the "Horizontal" section of this Troubleshooting guide.

STEREO ADJUSTMENTS
Adjustments were made using MTS TV / Stereo. Generator connected to. antenna terminals.

VERTICAL
Inject a vertical signal at pin 27 of IC501, if vertical deflection is

now present, check pins 27, 2S, and 29 of IC50l. If the vertical
deflection is missing, check IC301 and F386. Vertical linearity or foldover problems may be caused by C301, C305, C306, and C308 being defective.

MPX Level
Select stereo. mode on receiver. Select pilot, 1kHz audio. frequency, L-R modulating signal. Connect an oscilloscope to. pin BB on the MTS board, Adjust R659 for 900mV pop.

RFAGC
Tune in a picture. Adjust R152 counterclockwise then clockwise until snow just disappears. until snow appears,

SUB BRIGHTNESS
Tune in a picture. Set brightness, contrast, and color to. minimum. Adjust R257 for just visible highlights. . Tune in a color bar pattern. Connect an oscilloscope to. the red cathode. Adjust R552 for 150V pop. Tune in an active channel. Adjust R551 for proper flesh tones,

Stereo Filter
Select stereo. mode on receiver. Select pilot, 1kHz audio. frequency, and L-R modulating signal. Connect an oscilloscope to. pin 36 of ICGOL Rotate RG50 fully clockwise, then counterclockwise to. a po.intjus.tp.asLwhere wav.efo.rm is atminimum .. isto..rtion d

RASTER
Check the CRT and CRT vol tages. If red is missing, check pin 15 of IC501 and Q908.1f green is missing, check pin 17 of IC501 and Q909.lfblue is missing, check pin IS of IC501 and Q910.

HIGH VOLTAGE SHUTDOWN TEST

. . Apply 120VAC, turn the receiver on, and press reset button. Momen...... !IDly.~hQrtlf:XJQ ..IP.:R •.R~£~i.y~.LshQulgJQs~.ras.teLandsQund.lt the receiver does not lose raster and sound, the shutdown circuit requires repair. To. resume normal operation, remove AC Power, wait 10 seconds then turn receiver on.

IftheIaste[hasa.ke~stone.sha9.e,.c::heckJAQ2.Jfthelas.terhas...
height or width problems, refer to. "Vertical", "Horizontal", "Power Supply" sections of this Troubleshooting guide. or

Stereo

veo

AFT BALANCE
Open the link between the IF input and Ql61 by unsoldering the base

Select stereo. mode on receiver. Select pilot, 1kHz audio. frequency, and L+R modulating signal. Rotate RG51 fully clockwise, then slowly counterclockwise until stereo. indicator on screen appears.

IFAGC HORIZONTAL
Determine if the receiver is in shutdown, refer to. "High Voltage Shl.iioown"··sectlonofililsTroubleshoot1nggiiide:Uilie···l'eceiver is not in shutdown, inject a horizontal signal at base of Q404. If horizontal deflection is now present, check Q402, and pins 21 thru 26 of IC501. If horizontal sweep is missing, check Q404, T46l, D302, D406, D408, and D47l. The high voltage rectifier is part of T461 and if defective will affect the performance of the horizontal circuits. Horizontal linearity or foldover problems may be caused by C440, C442, C444, C446, and L441 being defective. Inject a video. IF signal at IF input and check for video. on CRT. If video. is present, check tuner and tuner control circuits. Check for a
~"id~c-"~Jt:,el!.:~fc~,--~~,-p!,~"-4-5,c-~IG501,,,,!f,,t.~e-",~!e~e£c~,,,!,s,p~ese!!t,---refer

Separation
§~l~.t. .. l~r~()Il1()<:1~ ... s ..)Il r~~iy.~r, ..§~l~t.l?il()t, ... ( ~.()QR2: a,1,I4i().fr~ql,l~.I1c..y, and right modulating signal. Connect IDt oscilloscope to. positive lead of left speaker. Adjust RG53 forminimum amplitude of waveform, Change audio. frequency to. SkHz. Adjust RG52 for minimum amplitude of waveform, Repeat until no. further adjustment results in an amplitude decrease of waveform.

A"-~"-<-~'-'~}ead~G-Giii"icet--a'-BG--;;GI~iii~te~--tv---t\i>juii0ti-Gii'Gf-R'--1-93-@1cl.'R'1'7-4~ Apply 3.0V to. pin 7 of IC501. Turn receiver on and adjust R15S for 4.5V. Remove DC supply and restore IF line.

SIDE DPC
Tune in a crosshatch pattern. Adjust RD5l, on the DPC board, for straight lines at the right and left sides of the pattern.

to. the "Video." section of this Troubleshooting guide. If the waveform is missing, apply AGC bias to. pin 5 of IC50 1. If the waveform is now present at pin 45 of IC50l, check pins 2, 5, and 50 of IC50l. If the waveform is still missing at pin 45 of IC501, check Q161 and IC50l.

WIDTH
Adjust RD50, on the DPC board, so. that the width of the picture is equal on the right and left side when the brightness is varied from minimum to. maximum.

TEST EQUIPMENT
Test equipment listed by participating manufacturer illustrates typical or equivalent equipment used by Sams engineers to obtain measurements. This equipment is compatible with most types used by field service technicians.

AUDIO
Check for an audio. waveform at pin 39 of ICG01. If this waveform is missing, check pins 4,51, and 52 of IC501, Q601, and Q602. If the audio. waveform is present at pin 39 of ICGOl, check for audio. waveforms at pins 4 and 14 of ICSOI. If the waveforms on pins 4 and 14 are missing, check ICS01 and ICG01. If the waveforms are present at pins 4 and 14 of ICSOl, check Q604, IC305, QS08, QS09, QS07, and IC6l0. Check pin 8 o.fQ604 for .2V at minimum volume and 8.8V at maximum volume,

HIGH VOLTAGE SHUTDOWN

CAUTION: When defeating the high voltage shutdown circuit, do. not exceed the maximum high voltage specified on the schematic, as this may cause excessive Xsradiation and damage to. the CRT and associated components. Monitor the high voltage while

COLOR TEMPERATURE
Tune in a picture. Set brightness, contrast, and color to. minimum. Set R95S, R956, and R957 to. minimum, set R952 and R953 to. midrange, screen control to. minimum, and S20l to. service position, Adjust screen control until a barely visible line of one predominant co.lo.r appears. Adjust R95S, R956, and R957 for a white line. Return S201 to. normal position, set the brightness and contrast to. maximum. Adjust R952 and R953 for best white balance of the picture. Check tracking at high and low brightness levels and repeat IJIU"<;UUll<; if necessary

Equipment
Oscilloscope Generators RGB Multiburst Signal Color Bar TV Stereo Digital YOM Frequency Meter Hi-Voltage Probe AcceSSOry Probes Isolation Transformer Capacitance Analyzer CRT Analyzer AC Leakage Tester Inductance Analyzer Flyback Yoke Tester TV Stereo Power Monitor Field Strength Meter Transistor Tester Video Analyzer

Sencore No.
SC3lO0 CM2000 VG91 VG91 VG91 SC3100 SC3100

troubleshooting.
The high voltage is monitored by D47l rectifying pulses from T46l. Should the high voltage increase, the voltage at base of Q47l, will increase and trigger Q471 to. conduct, and shutdown the receiver. To. troubleshoot, place a jumper between pin 22 of IC501 and ground. The set should return to. normal operation. If the set does not return to. normal operation, refer to. the "Power Supply" and "Horizontal"

VIDEO
Inject a video. signal at pin 45 of IC501 and check for video. on the CRT. If video. is present, refer to. "IF AGC" section of this Troubleshooting guide. If the video. is missing, check for a video. waveform

HPZOO
TP212 PR57 LClOI, LCI02 CR70 PR57 LClOI, LClO2 TVA92 SR68, PA81 SL750 TF46 VG91, TVA92

sections-ofLi.isTroubleshooting'guide~If-thesetreturnstononnal
operation, check for approximately 20.3V across C47l. If voltage is missing, refer to. the "Power Supply" and "Horizontal" sections of this Troubleshooting guide. If the voltage across C471 is correct, troubleshoot the failsafe circuit. Voltages Taken with TV In Shutdown IC50 1 Pin 22 1.6V TP-X 2V

arpin 16 of IC50L If the wavefotm is missing at pin 160.f IC501,

check Q141, Q202, Q21l, Q27l, and pins 33, 35, 36, 37, and 38 of IC501. If the waveform is present at pin 16 of IC501, check Q290 and S20l.

CONVERGENCE AND PURITY

The yoke is bonded to. the CRT and convergence adjustments are no.t recommended, and purity

CHROMA
Check for proper chroma waveforms at pins 15, 17, and 18 of IC501. If waveforms are missing, check IC501. Check the 3.58MHz oscillator at pin 13 of IC50l. If the proper chroma is present at pins 15,17, and 18 o.flC501, refer to. "Raster" section of this Troubleshooting guide.

o
TELEVISION SCHEMATIC
continued

SET 3335

Page 2

SEE ICA02 PIN is

M903 26

P903 26

,
: 2SC2068:

SEE T461 PIN 9 PAGE 2C X

~q~~~_~l!.T~

~~~ \~A02 ------f'='--.,_:w.;=----+

10

RS07 100

,,
FW70 3300

SEE ICMOl PIN 7

r-----11

SEE lCA02 PIN 12 C214 .01

SEE lCAOl PIN 16 PAGE 2G

R262 lS00

, ,

SEE ICAOl PIN 16

SEE ICMOl PIN 9

,-o----TO ...

CRT SHIELD

SEE QM04

BASE

PAGE 3C

~q~~~~r-?~
,
: 2SC2068, c90s1 R9S7

M902

P902A

~
FOCUS RANGE SKV TO 7.SKV

J, .1 T47o,..F I
C930

r-----~-------t , , ,

'

211V

CD09 .1

~'--l--~'~-------'
• RD13 27K 2SA101SY PIN AMP SIDE RDDS 20K

CD08 .1

GREEN SOOO

"*

....

C902 .001 2KV

I
G2

RD11

RD16 10K

C44S 4.7p.F 160V RDOS 3300 1% Ml RD10 1000 -28.0V C330 10p.F -28.0V RDSO HORIZ WIDTH SOOO -28.0V VOLTAGES TAKEN WITH SIGNAL ADDITIONAL SCHEMATIC NOTES. SEE PAGE 1

SEE CRT FII..AI.4ENTS PAGE 2D

A PHOTOFACT STANDARD NOTATION SCHEMATIC AS

A2 Al

A6 A7

AS

co Howard

WITH

W. Some

'AM41"ffliifii
&: Co.

1994

A4

Al

A3

A6

A7

SET 3335

Page 1

TUNER INFORMATION
IC301 TA8427K ICSOl TC4053BP

IC FUNCTIONS

IC501 TA8864AN

TUNER VOLTAGE CHART

Pin
+32V +5V CLOCK DATA PRDIENA BM

VHF Low Band

32.0V 5.0V 2.9V 2.5V l.1V 8.7V

VHF High Band

32.0V 5.0V 2.9V 2.6V l.1V 8.7V

UHF Band
32.0V 5.0V 2.9V 2.5V l.1V 8.7V

Pin
AGe NC NOTE:

VHF Low Band

4.5V 1.6V

VHF High Band

5.9V 4.1V

UHF Band
6.6V 5.6V
5 1---+-+_---1

VHF Low Band voltages taken on channel 2. VHF High Band voltages taken on channel 7. UHF Band voltages taken on channell4. ICM02 MC144143Pl

TUNER TERMINAL GUIDE

L-

LNG/SCK CT/SDATA

18 17 10~------~

~CO~N~n~G 16

+5V

DATA

IF

AGC

RF

+~V (DIGITAL

15 14

11

00

...

,~

0
~

0
BM

]j_

•
NC

BLUE 8 HORIZ SYNC

13

14

9 VSS (DIGITAL)

VSS (ANALOG) 10

15

40
39

+32V

CLOCK

PRDIENA

IC610 TA8200AH

17

38

37

36

RIPPLE nLTER

Vee 7 8

PWB GND MUTE 10 11 12

20~----

SCHEMATIC NOTES
Waveforms and voltages are taken from ground, unless noted otherwise. Waveforms taken with triggered scope and colorbar signal. Waveform voltage is peak to peak. Timebase is per division. Waveforms shown at 10 divisions. Supply voltages maintained as seen at input. Voltages measured with digital meter and a lO00~V RF signal, with colorbar pattern, applied to antenna terminal. Controls adjusted for normal operation. Capacitors are 50 volts or less, 5% or greater unless noted. Electrolytic capacitors are 50 volts or less, 20% or greater unless noted. Resistors are 1I2W or less, 5% or greater unless noted. Value in ( ) used in some versions. Measurements with switching as shown, unless noted. Rated voltage shown on zener diodes. Q604 (IC604) TA7630P
1 VEE HCH-1 23 32

"*"
-+
"m

I
TONE CONTROL

Circuitry not used in some versions.

2
.. ~.

Circuitry used in some-versions,

Ground Chassis ground Common tie point Taken from common tie point
CIRCUITRACE

~I
BASS BAL

5 REF 6R 7

CH-1 VOLUME ~ BALANCE CONTROL

-1

CH-2 VOLUME BALANCE CONTROL

I
CH-2 TONE~ CONTROL

16 1~ 14 13 12 11 10

24

I~

BASS

r'-~
BIAS AND DC CONTROL CIRCUIT

vec
L TREB

-&
6

::N

25

30

1- ~

C_H_D

/_D

RM4_V_P_~~~~~~~~~-~-I

::

8 VOL

II Schematic
A-

'---

BASS 9

® : Voltage source tie point.

Cabling: Heavy lines reduce use of multiple lines.

Page 2

SET 3335

A TELEVISION SCHEMATIC

r---------,
SEE OAll BASE 1

NC TPBB R659 LEVEL~-<>-5000 BB SEE ICGOl PIN 39 PAGE 3A R211 300

,,

L171

t
INPUT

0211 AfolP

2SC1740S-0

R173 lOOK R174 1000

,,

,,
,
: :

XZOI
CZ47

UGL31GKNT' COMB FILTER 5:

L-+---:z

yOV42
C
4 4.3V 44

2SA1015Y CHRO~~_P_~

~-----,

3---~

i,
RV41~ 2200f 12.0V

II

6.!lV IF TO TUNER R161 120 L161 C162

49 ~.I:SV PART OF TA8864AN IC50 1 IF /VIDEO/CHROMA/DEF 6.7V 6.7V 1.5V

PART OF TA8864AN 4.2V IC501.JJ/VIDEO/CHROMA/.~y 11 12 13

7.8V 30 C509 .018I R565 220K

.011
9.0V(A) RF AGC RANGE 3.9V TO 6.7V

4~~!~t(ii~q
~
SEE 0262 COL~CTOR 9.0V(A) Cl13

(~i,
Rlll 22K

---------,

IF AGC RANGE 4.9V TO 7.0V

I

,
I I

:1'
I I

f---------·

Ll05

9.0V(A)

..

C512 SEE OA90 BASE PAGE 2G R265

.1.

C51Q 2.2}Lf

II l

X501 3.58MHZI C504

C511 01 .

R505 68K

9.0V(A)

lJ~b 1

R564 220K .......... '~A'

~ ...."\nJ

~
~

SEE lCA02 PIN 11

~------------------------------------------------------------------------------------

.Q11

INTERNAL CONNECTION

_j

C306 3300!,F

VOLTAGES TAKEN SEE OA15 BASE PAGE 2G ADDITIONAL SCHEMATIC NOTES, SEE PAGE 1

C446 .075

A PHOTOFACT STANDARD NOTATION SCHEMATIC

Al

WITH
Howard

';Mg'lii\iW.i
& Co.

W. Some

1994

MAIN BOARD

10 11 12 13 14 15 16 17 18

19

A
B C

E F

G
H

K
L M

A HOWARD

W. SAMS

@iji.Jiit-SM

PHOTO

Page 3

SET 3335

SET 3335

Page 3

PARTS LIST
CAPACITORS & ELECTROLYTICS
Item No. # # # # #
C440 C441 C442 C442 (1) C444 C445 C504 # C801 # C802,03 # C811,!2 C862 C888 C890 C902 C903 # COOl CG25 CG27 CM04

continued

MISCELLANEOUS
Item No. # # # # # #
F386 FSOI F802 HOOI (3) HOOI (1)(3) HOOI (2)(3) K910

CABINET PARTS
Notes
1 Amp,125V 5 Amp, 125V, Slow Blow 1.6 Amp, 250V, Fast Acting UHFNHF (EL852L1) UHFNHF (EL852LX1) UHFNHF (EL462L) (lR-9109A-K) 75 Ohms AC, Polarized

Rating

Mfr. Part No.

Description
Fuse Fuse Fuse Tuner Tuner Tuner IR Receiver Antenna Terminal Line Cord JaekJack Jack Jack Jack Switch Switch Switch Switch Switch Switch Switch Switch Switch Switch Switch Relay CRT CRT Socket Speaker Filter Delay Line Delay Line Crystal Crystal Crystal Filter Filter Filter PC Board (3) PC Board (3) PC Board (2) (3) PC Board (3) PC Board (3) PC Board (1) (3) PC Board (2) (3) PC Board (3) Transmitter

Mfr. Part No.

23144778 23144945 23144805 23321078 23321071 23321072 23120220 23864007 23176006 u--~'-2SS-oS-S-7'S°_""r-23365578 23365578 23365578 23365578 23344130 23145227 23145227 23145227 23145227 23145227 23145227 23145227 23145227 23145227 23145227 23146916 23312372 23312099 23902068 23151226 23303008 23250138 23250875 23153721 23153961 23153011 A5610690 23107976 23107920 23701662 23369229 23369322 23701665 23701664 23701762 23702042 23701663 23120038

Item
Model CF27C30
Cabinet Front Cabinet Back Knob, Control Knob,Power

Part No.

'

"',

24082352 .0075 3% 1.5KV 24082356 .0091 3% 1.5KV 24095947 .395%200V 24095758 .625% 200V 24082290 .0068 3% 1.8KV 24085978 4.7j.iF 160V NP 24353110 11pFNPO 24095670 .2220% 125V AC 24092300 .01 +80% -20% 250VAC ·~~-·~'24C92270-,,"--""'--""-~-' ~.904-7-29%"-12,5¥AG'''-~W"N .0047 400V AC 24092347 .0015 10% 2KV 24215331 330pF 10% lKV 24092341 470pF 10% 2KV 24211102 .00110% 2KV 24215102 .00110% lKV 24082095 .0183% 630V 24704335 3.3j.iF 20% 16V Tantalum 24704106 10j.iF 20% 16V Tantalum 24085970 10j.iF 20% 16V NP part.

23419903 23425509 23443586 23443594

# POOl # P801
'/.1(JV.L

Models CF26C30nv28C30
, el1iJinelFWrti Cabinet Back Knob, Control Knob, Power ''234t9922 23423485 23443546 23443545 - '.,.

nC"/u

Exr/mdio :Left
EXT Audio Right Left Variable Audio Out Right Variable Audio Out Video Service Power Channel Up Channel Down Volume Up Volume Down Function TVNideo Cable Speaker On/Off Reset Power A68AEG20X05 A66ADT18X02 CRT 3.5" X 2 3/8", 18 Ohms, 2W Comb

# For SAFETY use only equivalent

replacement (1) Used in models CF26C30 and TV28C30.

# # # #

PS02 PS07 PS08 PVOl S201 SAOl SA02 SA,O~ SA04 SA05 SA06 SA07 SA08 SA09 SAlO SR81 V901 V901 (1)(2) V90IA W661,62 XZOl (2) X201 X201 (2) X401 XSOl XAOl Z101 Z141 Z601

Created with pride by the employees of Howard W. Sams & Company. J. Barker; B. Bryant, B. Buchanan, T. Clensy, D. Cobb, G. Farrell. B. Fink. M. Herkless, J. Kocha, J. Limp, F. Malek, B. Medaris. R. Raus, B. Skinner; J. Young

503kHz 3.58MHz 4MHz SAW 4.5MHz 4.5MHz Close Caption (PB3492) CRT (PB2454) CRT (PB2516) DPC (PB3535) Main (PB3534) Main (PB3609) Main (PB3871 MTS (PB3420) (Cf-9584)

replacement part. (1) Used in model CF26C30. (2) Used in model TV28C30. (3) Contact PTS Electronics Corporation for replacement; part number.

# For SAFETY use only equivalent

order by manufacturer's

SET 3335

Page 4

Page 4

SET 3335

ope
3 4 5 6

BOARD

PARTS LIST

A
B C D E

12

DPC BOARD, GRIDTRACE LOCATION GUIDE

COOl C002 COO5 C006 COO7 C008 C009 COlO COl1 C015 0001 L-6 E-4 1-5 K-3 K-2 L-5 L-5 L-3 B-5 J-8 L-8 Q002 Q003 ROO1 Roo2 R003 J-7 L-4 M-7 0-3 1-5 J-6 1-7 K-8 K-8 K-7 L-2 L-3 M-4 K-5 K-5 M-2 K-6 K-7

SEMICONDUCTORS
(Select the replacement that gives the best results.)

Item No.
D204,05 D206, 10, 11 D246 D290,91

Type No.

Mfr. Part No.

A7150258 23118859 23118859 A7150258 23118859 A7150258 23118859 A7150258

NTE Part No.

NTE177 NTE177 NTE177 NTE177 NTE177 NTE177 NTE177 NTEl77 NTE552 NTE552 NTE552 NTE177 NTE177 NTE5018A NTE5018A NTE5018A NTE552 NTE552 NTE580 NTE5014A NTE5014A NTE5014A NTE50 11A NTE50 11A NTE50 11A NTE552 NTE5013A NTE177 NTE177 NTE5021T1 NTE177 NTE177 NTEl77 NTE177 NTE531 0 NTE5330 NTE552 NTE552 NTb519 NTE5405 NTE552 NTE519 NTE552 NTE552 NTE552 NTE552

ECG Part No.

ECG177 ECG177 ECG177 ECG177 ECG177 ECG177 ECG177 ECG177 ECG552 ECG552 ECG552 ECG177 ECG177 ECG5018A ECG5018A ECG5018A ECG552 ECG552 ECG580 ECG5014A ECG5014A ECG5014A ECG5011A ECG5011A ECG5011A ECG552 ECG5013A ECG177 ECG177 ECG5021T1 ECG177 ECG177 ECG177 ECG177 ECG5310 ECG5330 ECG552 ECG552 ECG519 ECG5405 ECG552 ECG519 ECG552 ECG552 ECG552 ECG552

TCEPart No.
SK9091 SK9091 SK9091 SK9091 SK9091 SK9091 SK9091 SK9091 SK9000 SK9000 SK9000 SK9091 SK9091 SK9A1 SK9A1 SK9A1 SK9000 SK9000 SKS036 SK6A8 SK6A8 SK6A8 SKSA6 SKSA6 SKSA6 SK9000 SK6A2 SK9091 SK9091 SK9971 SK9091 SK9091 SK9091 SK9091 SKS030 SK9972 SK9000 SK9000 SK3100 SK3951 SK9000 SK3100 SK9000 SK9000 SK9000 SK9000

noes

RD06

Roo7 R008 Roo9 RD10

lSS176 lSS133 lSS133 lSS176 lSS133 lSS176 lSS133 lSS176

ERB44-06 S5295G EU2A lSS176

D302 D318, 31,70 D401

F
H

lSS133
04AZ9.lZ UZ9.1BSC RD9.lESAB3 S5295G EU2A RU4AM 3JH41 04AZ6.8Y UZ6.8BSB RD6.8ESB2 04AZ5.6Y UZ5.6BSB RD5.6ESB2 TVR-1B RD6.2E(4)

A7978850 23118094 A7150258 23118859 23316325

D406 D408 D423

A7978850 23118094 23118338

23316315

D424

J
D471

23316309 A7568460 23115774 23118859 A7150258 A7117205 23118859 A7150258 A7150258 23118859 23316391 23115532 23115532 A7150351 A7801233 A7978850 A7150351 A7978850 23118094 A7978850 23118094 A7118305

K
L M

# D472
D491 , 92 D506, 07, 08 D561 D610, 11, 12,13

lSS133 lSS176
04AZ12X

lSS133 lSS176 lSS176 lSS133

D3SB60 RBV406M ERB12-01RK ERB12-01RK lSS178 SFOR3G42 S5295G

# D801
D840, 41, 42, 43 D846 D861 D862 D863 D864 D866
PHOTO

lSS178
S5295G EU2A S5295G EU2A 04AZ36X

A HOWARD

W. SAMS

1i§9!.u¥i34

D867 D870

# For SAFETY use only equivalent replacement part.

C
CLOSED CAPTION SCHEMATIC MTS BOARD

SET 3335

Page 3

1
~i~ ---lr-Q---iII-----"F-f-f ~~501
PAGE 2D

10

11 12

13

14

SEE lCAOl PIN 3 PAGE 2G SEE lCAOl PIN 11 PAGE 2G

18 Pt.401 17 Pt.401 16 Rt.427 1000 Rt.426 1

SEE lCAOl PIN 15 PAGE 2G

IC501 19 2C

A HOWARD

W. SAMS

Dlj!i.W"'.

PHOTO

MTS BOARD, GRIDTRACE LOCATION GUIDE

C609 C615 C617 C619 C620 C621 C622 C623 C624 C625 C626 C627 C628 CG01 CGI7 CGI8 CG21 CG22
VOLTAGES TAKEN WITH SIGNAL ADDITIONAL SCHEt.4ATIC NOTES. SEE PAGE 1

A-4 A-3 E-3 0-4 A-2 A-2 0-3 B-2 0-1 A-I 0-2 0-3 E-2 B-9 E-7 E-6 E-9 E-13

CG23 CG24 CG25 CG26 CG27 CG28 CG30 CG31 CG33 CG37 CG39 CG40 CG41 CS50 CS51 CS52 CS53 CS54

0-13 F-14 E-14 0-12 0-13 0-12 0-12 C-13 C-12 B-12 F-9 C-13 A-12 A-6 A-6 A-5 0-7 F-2

CS56 ICG01 PG01 PG02 Q604 Q865 QG02 QG03 QG04 R609 R610 R611 R612 R613 R624 R625 R627 R629

0-5 A-10 F-10 F-4 C-2 F-3 B-7 C-7 0-7 F-8 F-8 B-3 A-3 B-4 C-1 B-1 A-3
B-3

R646 RG02 RG03 RG05 RG06 RG07 RGI1 RG13 RGI4 RGI5 RG17 RGI8 RG26 RG30 RG34 RG39 RG40 RG41

E-4 E-6 E-5 B-9 C-9 B-8 0-9 C-8 0-9 0-9 E-5 E-5 E-12 C-12 B-12 E-9 B-12 B-13

RG42 RG43 RG44 RG50 RG51 RG52 RG53 RG60 RS52 RS53 RS54 RS55 RS56 RS57 RS58 RS59 RS60 RS61

E-8 0-7 E-7 B-8 B-7 B-13 B-14 C-9 B-6 B-5 0-6 0-6 C-4 A-4 0-4 B-4 A-5 0-5

PHOTOFACT

STANDARD

WITH

<C> Howard W. Soma &: Co. 1994

'4MYil.diW

NOTATION

SCHEMATIC

SET 3335

Page 4

PARTS LIST
SEMICONDUCTORS
(Select the replacement

continued

continued

SEMICONDUCTORS
(Select the replacement

continued

that gives the best results.)

that gives the best results.)

"em No.
D871

Type No.
UZ15BSB 04AZ15X 04AZ15Y 04AZI5Z 04AZ36X UZ36BSA RU4AM RU4Z
'~,~n~ ,',,_

Mfr. Part No.

23316339

NTE Part No.

ECG Part No.

ECG5024A ECG5024A ECG5024A

TCE Part No.

Item No.
Q423 Q471 Q601,02 Q604 (lC604) # Q801 (lC80l)
--~~, ----

Type No.
2SD880-Y 2SD2023E 2SAI015-0(TE) 2SC1740S-Q 2SC1815Y TA7630P STR57041

Mfr. Part No.

A6848520 A6534036 23114528 B0356190 23319592

NTE Part No.

NTE152 NTE152 NTE290A NTE85 NTE85 NTE1576

ECG Part No.

ECGl52 ECG152 ECG290A ECG85 ECG85 ECGl576

TCE Part No.

SK3440 SK3440 SK9132 SK3122 SK3124A SK7672

23316370 23118338 23118052

NTE5024A NTE5024A NTE5024A

D878 D883 D884 ··""",~ge,g-5'_." D890,91 DAI0,11 DA20 DB18

".

- ---R-zivi--------

-23ii:8339
A7150258 23118859 A7150258 A7150258 23316312 A7150258 23118859 A7568460 23316582 A7568752 A7150258 23115922

---N'I'E51U'"
NTEl77 NTE177 NTEI77 NTEI77 NTE5013A NTEI77

NTE580 NTE580

SK15A SK15A SK15A

~E<::G510 .
ECGl77 ECGl77 ECGl77 ECGI77 ECG5013A

ECG580 ECG580

lSS176 ISS133 ISS176 ISS133 04AZ6.2Y UZ6.2BSB ISS176 ISS133

SK5036 SK5036
_·~w~_·,,,_·
~c~

.... ~Q802.
Q803 Q804 Q840 (IC840) Q863 Q865 (IC865) Q870 Q902,03,04 Q908,09,10

,2SAW2Q-Y""

'~_"'O'_''"W_·".'·.-·'''.'~_._'~~'~.

~--1ITE25' ··At534I-45-·'-'~'~--A6317440 A6333346 23318299 A6317440 B0372960 A6532853 A6317440 A6319400 A6002010 23114530 A6317764 23114528 NTE85 NTE293 NTE85 NTEI902 NTE383 NTE85 NTE376 NTE290A NTE290A NTE85 NTE85 NTE85 NTE85 NTE85 NTE85 NTE290A NTE290A NTE85 NTE85 NTE37 NTE85 NTE290A NTE293 NTE85 NTE152 NTE152 NTE2357 NTE290A NTE2357 NTE85 NTE290A NTE2359 NTE85 NTE290A NTE85

.,.",." EeGZS
ECG85 ECG293 ECG85 ECGl902 ECG383 ECG85 ECG376 ECG290A ECG290A ECG85 ECG85 ECG85 ECG85 ECG85 ECG85 ECG290A ECG290A ECG85 ECG85 ECG37 ECG85 ECG290A ECG293 ECG85 ECGl52 ECGl52 ECG2357 ECG290A ECG2357 ECG85 ECG290A ECG2359 ECG85 ECG290A ECG85

SK38liT
SK3124A SK3849 SK3124A SK3962 SK9138 SK3124A

--~",-,.~",'-''''_

,,",

-.~

SK9091 SK9091 SK9091 SK9091 SK6A2

ECGl77

NT.E177
NTE552 NTE598 NTE552 NTEI77 NTE615P NTE615P NTE50 11A NTE5011A NTE50 11A

EGG!??
ECG552 ECG598 ECG552 ECGI77 ECG615A ECG615A ECG5011A ECG5011A ECG5011A ECGl77 ECG519 ECG519

DDOI DD02 DD03 DD04 DE30 DE35

TVR-lB
ERC20-06 IS1887A ISS176 UPC574JL UPC574JM 04AZ5.6Y UZ5.6BSB RD5.6ESB2 TLS153FA ISS133 lSS176FA ISS178 TA8427K TA8864AN TA8200AH ~47C430N-U803 UPD6336C CXA11 24BS TC74HC157 AP MCI44143Pl TC4053BP TA75358P 2SA1 015- Y(TE) 2SC388ATM 2SC1815-Y 2SC1740S-Q RN1204 2SC1815-Y 2SA562TM-Y(T) 2SC1569FA-5 2SDl556(E)

23316309 A8636541 23118859 A7150351 B0378560 B0384703 B0376795 23904309 23318627 23904295 B0487885 23319985 B0470532 B0347500 A6534053 A6708871 A6317440 23114528 A6002040 A6317440 A6509154 A678971D A6871313 23319202

DESO
DM100, 110 DR81 IC301 IC501 IC610 ICAOI ICA02 ICGOI ICMOl ICM02 ICSOI ICS05 Q141 Q161 Q202 Q211 Q262,63 Q271 Q290 Q402 # Q404 Q421 (IC421)

NTE177 NTE519 NTE519

SK9091 SK9091 SK9000 SK9859 SK9000 SK9091 SK9976 SK9976 SK5A6 SK5A6 SK5A6

QAIO
QA11 QA12 QA13

QA14 QA15 QA90 QA91 QDOI QD02 QD03 QE05 QE35 QG02 QG03

NTE7068

NTE4053B NTE928M NTE290A NTE85 NTE85 NTE85 NTE2359 NTE85 NTE290A NTE376 NTE2302 NTE1910

MC7809CT

ECG4053B ECG928M ECG290A ECG85 ECG85 ECG85 ECG2359 ECG85 ECG290A ECG376 ECG2302 ECG1910

ECG7068 -

SK9091 SK3100 SK3100

SK4053B SK3692 SK9132 SK3132 SK3124A SK3122 SK9959 SK3124A SK3114A SK3219 SK9422

QG04
QM03 QM04 QS07 QS08,09 QV42 QV70

2SC1815-Y 2SC2655- Y(Q L78MR05-FA 2SC1815-Y TA78LOO9AP 2SA949-Y(C) 2SC1815-Y 2SC2068 RN1201 2SA933S-Q 2SAlO15Y 2SC1815-GR 2SCI740S-Q 2SC1815Y 2SC1815Q RN1201 2SCI740S-Q 2SC1815Y 2SA564A-Q 2SAI015Y 2SCI740S-Q 2SC1815Y 2SB688-0(BS) 2SC1815-Y 2SAI015- Y(TE) 2SC2655-Y(C) 2SC1815-Y 2SD880-Y 2SD2023E RNl003 2SAI015- Y(TE) RN1203

SJC".3219
SK9132 SK9132 SK3124A SK3122 SK3124A SK3124A SK3122 SK3124A SK3932 SK9132 SK3122 SK3124A SK9415 SK3124A SK9132 SK3849 SK3124A SK3440 SK3440 SK9742 SK9132 SK9742 SK3124A SK9132 SK9959 SK3124A SK9132 SK3124A

A6002010 23114528 23314055 23114528 A6625365 A6317440 A6534053 A6333346 A6848520 A6000030 A6534053 A6002030 A6317440 A6534053 A6002040 A6317499 A6534053 A6317440

2SC1815~Y
2SAI015- Y(TE) RN1204 2SC1815BL(T) 2SAI015-Y(TE) 2SC1815-Y

# For SAFETY use only equivalent replacement part.

# For SAFETY use only equivalent replacement part.

Page 3

SET 3335

B AUDIO SCHEMATIC
PS07 LEFT ( "'o]f---, " VAR 'T" AUDIO RS100 OUT 1000

CG39 ~~irr~6ri>2:---------P-<;J-~-'-----~-t'.,'" PAGE2B RN1203 SEE ICAOl PIN 1 PAGE 2G PG02

BQ BQ

RG39

7F¢'_· __ '""0,,,0~0_--:;3<a19 IN

~:s~
OS08 2SC1815BL BUFFER ,8AV L-OUT ~};F ~~~8 PG02 9.OV RS32 47K RS26 47K 9.0V

OG04 AM.-P 1.9V-0

-;>--_-oBP NC RG43 4700

\.::::Ir
i

+---------nt9
RNW03

6V"MONO 4.5V t: C;:8:--fF·--'Wv---<B>-0-B:<l0--;r------'102"i

'
SAP

9.0V 14

1-:-:---1.0,

I
;

R610 C626 LEFT ~--<>__PG:<l0-l-~lONO~O~~~'f¢'--;~IN BJ BJ " 2 4.4V

TA75358P PARTOF lCS05

~I J P
~'---__'

CS51

R638 C643

13.8V 7

~_P-<G>-01 -O-'_2 ... MO~0..,2'i!' __ 7 r2"f"-¢'---;4-t~FT BG BG "IN R640 270

C646 4y

~~ 1-:7:-~-_'_-'9J-

2SA1015Y RG44 3300

RG60 OUT 2700 4.5V 6 1%

RS42 5600 RS55 10K

-----?K
LEFT
P603 P603

CHANNEl ~~61

12.0V OV~NC OV~NC OV f-;"s- NC

ILoUV

RS54 12K R624 150K RS61 1000

~:1=o3 AMP

9,oHv4'3~G02) AM

+----8,-1

~J

C611~ 001 .

33

RG07 1000
~}

RG42 33K ..
~

.1Ilii!I
I

SAP4.;~ ~21;-~'9~j-jJ.l-F--1 RS2bi.---+---..M---1r::-,3::-1 6200 RS04 4700 RG06 ,. CXA 1124BS 6200 lCGOl 1% MTS DECODER v .10# 'i"
m ••••••••••••••

TA7630P 0604 RS56 (lC604) AUDIOCONTROL 10K

m 7 15 :'.OV

U1

EXT LEFT iC' AUDIO

::::~r--~ _
!

16

SEE ICAOl PGOl ~~~3 ~l~E 9 2G --B<M>---------<B>-M---"-M---------;i3

--r+'

g~ 'CG2
LOW

c :
.W

SAP

~;:_1L+R OUT 35 1.2V MAIN IN 1.2V L+R OUT 1.2V R-OUT VC:~~ CG17 RG17 4.7,fF 100 PG02

TC4053BP lCSOl SWITCHING

:~ir
10~ 12.0V 2SC1815BL OS09 BUFFER 8AV R625 150K RIGHT

~wl~r··~~
9.0V TA7538P PARTOF ICS05

SEE ICAOl PIN 25 PAGE2G

.. -.:!I-~.~. ...

~-~-l'T."-.,-;1, ..-.

4.8V

1
RS101 1000 R639 2700 C642

PS08

36

sEPAAA~rg~lr<-·--4-·?r--·¢'~~~~~:2:4

CG22±

.I

RG52 HIGH SEPARATION 5000

(.004~)

::w::

1-,"'::-..-1~.j!: ......-~",_-_:<l,-,-<_,>-,
1-;--4 RG05 lOOK

~-___.·······c---R-~~-~""f""---~!:-ii 9.gV ..

9.0V 4

f~ r-;,--

3 Rv3

~~'

nJ

3.8V

RIGHT VAR AUDIO ~ OUT CS50 PGOl

=1

TA8200AH lC610 AUDIOOUT

... 'tF
"

2ft"
"2!,~

C649 RIGHT Rg~'''''''2::---~~_4?.n_'''I~!I-¢'

RIGHT
__'103 .

CHANNEL

BHBH

~K~~62

22 4.5V

CG33 47jJ.F..-

*' ..

r----33 ~5~
CSll 10¢'.L

RS38 47K

12.0V 3 OV

VIb
RS52 12K

9.0V

C612 .001

NC

----s

:.~v
1SS17~.

P603t.

if'

RS2B 2000

RS03 4700

RG51 VCO 50K

RG15 .-_4"'7'!'!K 1%

-;-;:1 I VCC 15 1.2V VCATC 1.9V

Fl
~

RGll r-_~75\1\O""K~r_;_.-I I SAP RG13 13 1.2V 47K

I!
SAP :.~~

PS02 EXT RIGHT@ AUDIO

_p_

12.0V CS03 10¢' "F

r
SEE lCA02 PIN 7 PAGE2H PG02 BD R629 4-'\7NO~0--~--_=_I8 C619~ ljJ.F J. R646 1000 OV

GND

RS53 10K CS52 10jJ.F

RS60 1000 C641 4'!fF ,..~~-iF- "----:;-11 C644 F

7 4.5V

BAL

D6iJ.
20.0V

.6V

R648 2.2 C648 12 .

061 lSS176~

2*

'---------

91101"
NC NC NC OS07 4.5V 4.5V 4.5V

~i~ i~02
PAGE2H

P-<G>-02 BC

~fJ-MIN
8.8V MAX

4f.t 16V +-----~"-----~5~ .

VCC~

1% RG14 t-_~4~7~K_---;--;i I LPF 1% 14 1.2V RG50 ".., FILTER I. 20K

tzQ--

RN1204 SWITCHINGCONTROL

Ll.,

+-__
VCCt-::-5---1

C645 R699 4 -1 r7,.:F¢'_---'\10N'0~--", FILTER • 6 6.8V

-:;g-

-;s- NC

SEE ICA02 1.8V_O PIN 5 -----~r""1~ _PA_G_E_2_H_ CS04 10jJ.F

J.

~i~ ~CA02__
~ RS36 22K

RG29 P-<G:r02~._-'""0"'0~0--_<r--::_i BE C60~

BASS 9 5.4V

9.0V

R613 220K

4.7jJ.F ~

STRI-3.BV 2

RG02 '''O;;,.D

PG02 BL

'

-o-__

~i~ ~CAOl
PAGE2G

20.0V

.~'
r---wGND

j3GND

RG26 VOLTAGES AKENWITHSIGNAL T ADDITIONAL SCHEMATIC NOTES,SEE PAGE 1

CG'~F

PC INT2 1-VCAWGT 4.5V 41 4.5V VE 4.5V I TINE 1.2V

+-- __

---<

--'
.R66ci~ 470~ 9.0V ~------~-~TRE R61~~ 3900

A PHOTOFACT STANDARD NOTATION SCHEMATIC

r-_:3"'90~0=---iF_-_;;;;:_l 26 CG30 RG30 .0027 0"'0 H +-_3,,3"N__ --;;:;-! 30 RG34 ~-'V43\1\K------:;-;-i 1% 34

C615 ~ 4.7jJ.F ~

10 4.1V

L-

--l

WITH

GI;MiIii\@1.\i4
&:

Howard W. Sams

Co. 1994

PARTS LIST
Important Parts Information CONTROLS & RESISTORS
Item No.
R152 R158 R257 # R327 # R327 (1) # R336 R352 # R370 # R414 # R416 # R416 (2) j

continued

COILS & TRANSFORMERS

NTE Part No. Item No.
L061 Ll01 Ll02 Ll03 Ll04 Ll05 Ll41 Ll42 Ll45 Ll61 Ll71 L205 L301 lA09,10 # L441 L442 # L462 (1)

The parts listed here are those not usually available from a well-stocked supply cabinet or bin. equivalent parts, several alternates are shown from participating vendors.

FunctloniRating

Mfr. Part No.

FunctioniRating
Peaking RFChoke Peaking PIP Peaking PIP Peaking Peaking Peaking Peaking PIP Peaking Ferrite Bead Ferrite Bead Linearity Choke Yoke 110 Horiz 1.2 mH Vert 21.4 mH
0

Mfr. Part No.

23289101 23252923 23237977 23262828 23237999 23262827 23238712 23237984 23238562 23238560

On-Unit No.

• Where items may be replaced with

• On the parts lists, safety items are

marked with a # to remind you that only exact replacements are recommended for these items. • ...Wbenorde~lng.pBJ!S,.S!ateJbemQdeL number, part number, and description.

Obtaining Parts
Many of these parts are available from your local Sams authorized distributor or the m~nllf~l'tllr"'r nf. th",. ",nuinm",nt .C~II.~~m'"_ ·····_····_·_-,._···_··'···,_··-·-· ..·-·_,·---'-·r······_ ....•......... ..'.__ ..... __ . for the name of your nearest distributor:

# # # # # # #

R44I

10KRFAGC 24066926 200K APr Balance 24066922 2000 Sub Brightness 24066928 5.6 5% 2W Fusible 24339569 4.3 5% 2W Fusible 24000173 2705% 2W 24383271 50KHeight 24066924 10005% 1/2W 24552102 18005% 2W 24383182 33005% 5W Wirewound 24510332 4300 5 % 5W Wirewound 24510432 TOOO5%TWFusfble··· ·······24532102 .475% 1W .561W 275% 15K 1% 1/4W 13K 1% 1/4W 62001% 1/4W 22005% 2W
1l\'V"
",:-v",,,;,:'ouV:".LUt.:

F2W5D6 F2W4D3 2W127 HW210 2W218 5W233 5W243 F1W21O 1WD47

R448 R448 (2) R475 R478 R478 (2) R482 R495,96

R5$-!
R552 R659 R804,05 R808 R810 R866 R867 R870,71 R878,79 R880 R899 R920 R952 R953 R956 R957 R958 R960, 61, 62

24338478 24338568 24366270 24327153 24327133 24327622 24383222

l\ . n.LLre.", L. .A ~~Q:T~Q

23238705 23103940 23103880 23233092 23221962 2G27007505

2W222 L603 L604 L810 L860 Thru L864 L885 L886 L901 LAO 1 LA28 LD01 LD02 T401 T461 (2) T801 T840 T862

..... !...T! ..... '"

800-428-7267
Or consult the Sams Annual Index for the address of the original equipment manufacturer.

# # # # #

Participating Vendors
Information on test equipment and replacement parts is listed in these pages for the following participating vendors. Consult the Sams Annual Index for their current address.
# #

• Custom Components Corporation

(Chek-A-Color)

• NTE Electronics, Inc. (NTE) • Philips ECG Company (ECG) • PTS Electronics Corporation (PTS)
"
\J!'WII\lVI

# # RDOI # RE30 # RE37

~,.. ...,..,.. ..,..II"Io'"

v,

III\I~

• Thomson Consumer Electronics, Inc.

(SK, TCE)

RG06 RGl3, 14, 15 RG34 RG50 RG51 RG52 RG53 RG60

10K Sub Color 5000 Input Level 3.9M 10% 1/2W 7 PTC Cold Thermistor 1.1 5% 15W Wirewound 565% 3W 565% 2W 20K 1% 1/4W 10K 1% 1/4W 82001% 1/4W Varistor 1.2 5% 2W Fusible 200 Green Drive 200 Blue Drive 5000 Red Bias 5000 Green Bias 5000 Blue Bias 15K5% 2W 155% 1/2W 18K5%2W 105% 1/4W Fusible 6200 1% 1I4W 47K 1% 1I4W 43K 1% 1!4W 20K Filter 50KVCO 5000 High Separation 10K Low Separation 2700 1% 1/4W

24066926 24066927 2496395 24019002 24007873 24384560 24383560 24327203 24327103 24327822 24b00902 24000921 24066595 24066595 24066599 24066599 24066599 24383153 24000211 24383183 24545100 24327622 24327473 24327433 24066925 24066924 24066927 24066926 24327272

HW539

3W056 2W056

F1WID2

# # # #
2W315 HW015 2W318

Peaking SIP Ferrite Bead Ferrite Bead Ferrite Bead Choke Ferrite Bead Degaussing IP Peaking Ferrite Bead Choke Horizontal Drive Horizontal Output Line Filter Power Converter

23238709 23252905 23103880 23103880 23103880 23221746 23103880 23200664 23262996 23238562 23103880 23221686 23224915 23236254 23211892 23213513 23217126

TLN 1068 TFB4100AD F3140 TPW1459AZ TPW3217AD

# For SAFETY use only equivalent replacement part.

(1) Bonded part of CRT. (2) Focus and screen are part ofT461.

# For SAFETY use only equivalent replacement part.

(1) Used in model TV28C30. (2) Used in models CF26C30 and TV28C30.

Page 4

SET 3335

CLOSED CAPTION BOARD

MAIN BOARD, GRIDTRACE LOCATION GUIDE
C063 C065 C101 C102 C104 C105 ClIO Cll1 C1l2 C1l3 C141 C142 C161 C162 '"'C:i:-7-3~ C176 C201 C202 C205 C207 C209 C213 C214 C215 CZio C222 C223 C241 C260 C271 C300 C301 C305 C306 C307 C30S C309 C310 C311 C313 C314 C315 C317 C325 C330 C401 C403 C404 C410 C413 C416 C417 C419 C421 C422 C423 C440 C442 C444 C445 C446 C446 C44S C449 C463 C471 K-7 K-7 K-9 J-9 H-9 0-9 J-9 J-9 J-9 H-12 F-9 G-9 J-8 K-9 H-9 0-10 0-12 H-10 0-12 F-11 J-11 J-10 0-11 C473 C501 C502 C504 C509 C510 C5ll C512 C513 C514 C517 C601 C602 C604 "C6C5""~ C60S C611 C612 C630 C640 C641 C642 C643 C644
~u.,.;;)
"""~,.J!~

1
A-14 PV01 Q141 A-14 Q161 0-6 Q202 0-6 Q2ll C-10 Q262 F-10 J-6 Q263 Q271 M-12 Q290 A-3 E-9 Q402 Q404 E-9 H-5 Q421 Q423 0-16 Q471 M-4 C-6 .. QilOl .. Q602 D-15 QS01 1-9 QS02 C-1S QS03 C-S C-12 QS04 L-9 QS40 A-2 QS63 QS70 K-7 K-S QA10 K"C~ QA!! J-9 QA12 QA13 0-9 QA14 H-9 O-S QA15 QA90 F-9 QA91 H-9 QE05 J-7 0-9 QE35 QS07 J-11 0-12 QS08 QS09 E-15 QV70 H-18 ROO1 1-18 F-17 R002 F-19 Roo3 1-12 R065 O-S R103 J-S RI04 R106 J-3 F-1 R110 F-1 R111 0-3 R1l5 R141 E-5 R142 D-5 C-5 R143 R152 B-2 D-4 R158 D-9 R161 E-7 RI62 R163 L-14 L-11 RI64 0-16 R166 H-17 R173 R174 A-17 N-4 R204 K-2 R206 K-19 R207 A-ll R20S A-12 R209 N-ll R210 R2ll N-12 R212 R216 R217 R21S R223 R227 R229 R230 R233 R236 R237 R23S R240 R241 R244 H"8 I-S R246 F-2 R247 E-3 R24S H-2 R257 B-3 R260 H-5 R261 H-4 R262 F-5 R265 B-ll R266 C:-12 . R27! E-7 R272 D-10 R273 D-10 R276 D-10 R293 D-ll R294 C-11 R295 J-6 R301 M-11 R302 M-10 R303 M-10 R304 L-S R305 N-9 R306 1-7 R307 1-7 R308 C-10 R309 K-7 R313 J-9 R317 1-10 R31S J-S R327 J-9 R336 H-12 R352 J-8 R370 O-S R401 0-8 R402 0-9 R403 1-8 R406 F-S R410 K-7 R411 K-8 R414 J-8 R415 K-8 R416 K-9 R425 F-S R426 O-S R430 F-10 R440 0-12 R441 0-9 R444 0-11 R447 J-ll R44S R472 0-12 0-10 R475 N-10 O-S K-S 0-10 0-11 0-12 0-12 L-S K-ll E-16 H-1S 0-15 H-14 M-15 0-11 0-11 L-14 F-14 D-12 K-14 0-11 0-10 D-12 M-14 N-14 N-14 F-IO E-12 D-12 E-13 D-12 D-13 N-14 F-12 0-12 H-ll H-12 F-12 L-8 L-S L-9 L-8 K-11 K-10 K-11 D-14 K-12 E-14 E-14 E-15 E-15 D-15 E-15 D-15 E-15 J-14 M-14 K-15 E-16 N-15 D-14 1-12 L-12 J-12 M-12 E-17 F-16 R477 R47S R4S0 R481 R4S2 R483 R491 R495 R496 R501 R504 R505 R506 R507 RSQS R517 R551 R552 R560 R561 R562 R564 R565 R601 R6Q3 R606 R607 R61S R619 R63S R639 R640 R641 R647 R648 R659 R699 R803 R804 RS05 RSOS RS10 RS41 RS42 RS43 RS60 RS61 RS62 R863 R864 RS65 R866 R867 R869 RS70 RS71 RS72 R873 RS74 RS75 RS76 RS77 RS7S RS79 RSSO RSS1 N-15 M-15 N-14 M-14 M-15 M-15 L-13 F-16 F-14 H-12 J-10 0-10 J-ll J-ll J-12 0-10 F-10 F-9 D-12 D-12 F-9 D-12 F-9 O-S J-S H-S H-S H-S I-S B-15 B-15 B-16 B-15 C-18 C-17 H-8 B-18 B-2 1-4 N-5 J-1 K-3 H-5 H-5 0-6 0-3 0-3 0-3 E-3 F-3 H-3 D-3 D-1 RSS2 RSS4 RSS5 RSS6 RSS7 RS99 RA01 RA02 RA03 RA04 RA05 RA06 RA07 RAOS RA09 RAIO RAIl RA12 RA13 RA15 RA16 RA17 RA1S RA23 RA24 RA25 RA26 RA27 RA29 RA34 RA36 RA39 RA40 RA41 RA42 RA43 RA44 RA45 RA46 RA47 RA4S RA69 RA70 RA71 RA72 RA73 RA74 RA75 RA76 RA77 RA7S RA79 RASO E-3 F-2 D-2 D-3 B-13 N-3 C-8 C-8 C-S C-8 C-8 D-8 D-8 D-8 D-8 RA104 RA105 RA106 RA107 RA109 RAllO RAl12 RA130 RA131 RA251 RB2S RE03 RE12 RE30 RE36 A-7 A-S A-9 A-10 A-II A-12 C-7 E-10 E-10 C-9 L-13 B-3 1-6 E-7 M-12

10

11

1-12 H-12 H-12 J-10 H-12 K-10 0-10 J-10 K-10 J-10 0-10

o-s
O-S J-S

s-s-

r-s

I-S B-16 B-15 H-S B-17 C-1S B-18 B-1S B-1S

n so
,LI-.lU

l~lv
0-11 0-12 F-10 H-11 L-9 H-12 1-12 E-14 F-15 E-15 D-16 B-15 J-14 D-15 B-14 B-15 H-10 K-14 K-12 B-14 N-13 J-12 J-12 K-12 E-17 D-17 E-18 F-18 0-14 0-15 H-16 J-18 F-17 H-18 M-19 F-18 J-16 1-16 1-14 0-18 M-15

F-S E-ll D-11 C-ll D-S D-S D-S L-12 1-6 M-ll M-10 M-IO M-10 csn N-9 .! G-:V!)6~,,- . p..!. CV07 L-10 CV70 N-9 D204 F-10 D205 N-13 D206 N-14 D210 0-11 F-10 D2ll D-12 D246 D290 J-ll !,! !.. .r;~~! D301 D302 D31S D331 D370 D401 D402 D406 D408 D423 D424 D471 D472 D491 D492 D506 D507 D50S D561 D610 D611 D612 D613 D801 D840 D841 D842 D843 D846 DS61 D862 DS63 OS64 DS66 DS67 DS70 D871 DS7S DSS3 D884 DSS5 E-16 K-14 M-14 B-14 K-12 J-12 J-12 J-16 J-15 H-15 H-16 N-18 M-15 K-12 K-12 J-11 J-ll J-11 D-12 C-17 C-17 C-18 C-18 J-2 1-5 1-5 1-5 1-5 0-6 E-3 0-5 D-3 0-3 H-3 D-2 0-6 F-3 0-6 D-6 B-2 C-5

CAS9 CA90 CA91 CA92 CA100 CAllO CA120 CB64 CE30 CE35 CS03 CS04 CS10

DS90 DS91 DA10 DAll DA20 DB1S DE30 DE35 DE50 DM100 DM110 DR8l F3S6 FS01

A
B
C

P802
IC301 IC501 IC610 ICA01 ICA02 ICS01 K910 L061 LI01 L102 L103 L104 L105 L141 LI42 LI45 L161 L171 L202 L205 L301 L409 L410 L441 L442 L501 L603 L604 LS10 LS60 LS61 LS62 LSS3 L884 L8S5 L886 L887 LA01 LA28 M902 M903 MD02 P401 P603 P0802 P910 PDOIA PS01 PS02 PS07 PSOS

15-7

RE3'r

D
E
F
C.
U

M~r:f
E-10 M-9 M-10 M-S M-S L-S M-S M-10 L-S M-S L-10 M-S N-12 N-12 N-I0 L-10 N-9 N-9 N-9 N-9 N-7 A-2 A-6 A-7 A-7 A-S A-9 A-10 A-ll A-12 A-12 J-5 E-19 L-17 M-2 K-5 F-4
~A' lC .L'I'.I-.I."

d UJ
;;.L;

C646 C647 C648 C649 CS01 CS02 CS03 C810 CS11 C812 CS27 C840 C842 CS43 C845 CS60 CS61 C862 CS63 CS64 C865 CS66 C867 C871 C872 C874 C8S0 C881 C883 C884 CS88 CS90 CS99 CAll CA20 CA21 CA2S CA29 CA41 CA75 CA76

A-16 D-18 D-17 B-17 M-3 K-3 J-2 1-2 1-4 1-4 A-16 H-4 H-6 H-5 1-5 E-2 E-2 F-2 D-2 E-3 D-1 1-3 D-2 0-5 F-5 0-5 B-3 B-2 0-5 C-4 E-5 D-5 B-5 E-7 C-9 C-9 B-9 B-9 C-l1 C-12 D-13

G-i4
E-18 E-17 H-15 H-16 M-15 J-17 0-17 1-17 1-16 H-15 M-15 N-15

D-3
F-6 F-6 E-5 F-6 0-5 0-5 D-6 H-4 D-6 E-5 E-5 H-6

RA83
RA85 RA86 RAS7 RA90 RA91 RA92 RA93 RA94 RA95 RA101 RA102 RA103

D-7 D-7 E-8 D-9 D-9 D-10 D-10 E-9 E-9 B-11 C-9 C-8 B-11 C-7 D-7 C-12 C-13 C-12 B-7 B-7 B-.7 B-7 B-7 B-8 B-10 E-7 D-7 E-7 E-7 B-10 B-10 C-12 B-10 C-10 C-10 B-13 E-12 D-10 D-10 0-10 E-10 E-ll 0-11 0-11 0-11 0-11 C-10 C-7 A-6 A-7

RM100 RS03 RS04 RS26 RS27 RS28 RS32 RS36 RS3S RS39 RS42 RS43 RS100 RS101 RVOI RV27 RV70 RV71 RV72 RV73 RZ35 SA01 SA02 SA03 SA04 SA05 SA06 SA07 SAOS SA09 SA 10 SRS1 T401 T461 TS01 T840 TS62
...,.,n

>

;::
0

m
r-

n
~

A HOWARD

W. SAMS

@MMA.

n Co)
::I:
UJ

" .....
n

PHOTO

>

UJ

CLOSED CAPTION BOARD, GRIDTRACE LOCATION GUIDE

CMOI CM02 CM03 C!vi04 CM05 CM10 CM11 CM12 C-5 0-10 D-4 ~ "" ..... rr-o C-2 C-4 C-8 D-S CM13 CM14 CM15
l\...lY.1Vl
T"...,-.. "'1'\'1

CO
Co)

n
U1

i!

.Ie-"

D-7 F-S E-7

TP-X TP12 TPBB X201 X401 X501 XA01 ZIOI Z141 Z601

M-15 0-10 0-13 L-7 1-12 J-10 0-9 K-9 O-S H-8

F.. 4
F-10 1-2 1-6 D-2

QM04 RM01 RM02

hJ.'t'.lUJ

"""'-1'\"

F-2 F-9 E-2 F-2 H-2 D-2 C-6

ICM02 PM01 PM02 QM03

RM04 RM05 RM06 RM11

.,., ......

RM13 RM16 RM20

,n,~A'''t
.1'\..1.'1'''''''.1

RM22 RM23 RM24 RM25

D-S E-S O-S 0,,6 0-7 O-S H-3 H-10

RM26 RM27 RM2S P~A29 RM30 RM31 RM32 RM33

H-10 H-9 H-4 H-5 H-4 H-5 H-7 0-6

SET 3335

Page 3