VESTAX

SERVICE NOTE

MODEL: PCV-002

1. SPECIFICATIONS P. 2-P. 5
2. SCHEMATIC DIAGRAM P. 6-P. 10
3. PARTS LIST P. 11- P. 14
4. SPARE PARTS LIST P. 15- P. 16

Vestax Corporation Service Department

(2003-07-22)
Vestax NumbeModel Categorie Description PCB SYMBOL SHEET Specification
B050100200 PCV-002 CASE BOTTOM FRAME
VR Control 1
V012011200 PCV-002 C.F. MONITOR VOLUME VR13 50KB*2 L=15mm RS20112
V014511D00 PCV-002 VR CROSSFADER Fader VR17 1 100KB*2 RS4511DB6
J030470015 PCV-002 CONNECTOR DC JACK In-Out J6 1 HEC0470-01-630 DC 15V
B010100204 PCV-002 CASE FACE PANEL BLUE
H01MT90302 PCV-002 CONNECTOR GND TERMINAL MT-903
J010544010 PCV-002 CONNECTOR HEADPHONE JACK Phones J4 1 HLJ-0544-01-010
I04M781200 PCV-002 IC IC NJM7812 In-Out U20 1 12V REGULATOR
I05AN6884S PCV-002 IC IC AN6822S Control IC1 IC2 1 LED DRIVER
U10 U11 U12
U13 U14 U15
I010082L02 PCV-002 IC IC NJM082L Control 1
U16 U17 U2
U3 U4 U5
I012068L02 PCV-002 IC IC NJM2068L Control 1
I014556AL2 PCV-002 IC IC NJM4556AL Control In-Out 1 DUAL OP AMP
I014580L02 PCV-002 IC IC NJM4580L Control In-Out 1 OPERATIONAL
20KA*2 L=20mm
V014511201 PCV-002 VR INPUT FADER Control VR2 VR4 1 RS45112A6
T=45mm
S0222B1702 PCV-002 SWITCH INPUT SELECT SWITCH Control SW1 SW2 1 LBC22B17K SILVER
VR6 VR7
VR Control VR8 VR9 1
V0209L1200 PCV-002 ISOLATOR VOLUME VR10 VR11 20KC*2 L=15mm RK09L12D0C0G
V0209L1201 PCV-002 VR MASTER BALANCE VOLUME Control VR14 1 10KAC*2 L=15mm RK09L1240
V0209L1202 PCV-002 VR MASTER LEVEL VOLUME Control VR15 1 20KA*2 L=15mm RK09L12D0A1F
J011523110 PCV-002 CONNECTOR MIC JACK In-Out J5 1 HLJ-1520-01-3110(CLOSE)
V0209L1100 PCV-002 VR MIC LEVEL VOLUME Control VR16 1 10KA L=15mm RK09L1140A5K
V0209L1203 PCV-002 VR MONITOR VOLUME Control VR5 1 10KA*2 L=15mm RK09L12D0
X020100204 PCV-002 MANUAL OWNER'S MANUAL
S018802000 PCV-002 SWITCH POWER SWITCH In-Out S1 1 SDDLB880200-9
K030000100 PCV-002 Knob POWER SWITCH KNOB POWER SW
J025857A02 PCV-002 CONNECTOR RCA(4P)JACK In-Out J1 J2 J3 1 T5857AAAF, NICKEL(SILVER)
 CONTROLS AND FUNCTIONS
3 2 4 1 4 2 3
TOP PANEL

13 9

10

11

12

5 5

q POWER LED i PHONES JACK

The LED is lit when power is on. Use this jack to connect the head phones. Head
w INPUT SELECT SWITCH phones from 8 ohm to 600 ohm can be used.
Used to select the input (LINE or PHONO ) to be 150 ohm is recommended.
sent to each PGM channel. o MASTER LEVEL
e TRIM CONTROL Adjusts the signal level output from the LINE
Adjusts the input level of each channel. OUT jack on the rear panel.
r ISOLATOR (HI,MID,LOW) !0 MASTER BALANCE
Cuts and boosts each frequency range. The Adjusts the signal balance of the left and right
level is flat when this knob is set at 12 o'clock. side of the outputs from the LINE OUT jack on the
rear panel.
t INPUT FADER
Used to adjust the input level of each program. !1 MONITOR LEVEL
Usually set at the 7-8 position. Adjusts the head phone output level.
y INPUT LEVEL METER !2 MONITOR SELECT FADER
The LED level meters indicate the input signal When the monitor levels of PGM1 and PGM2
level of each PGM channel. are properly set, PGM1 will be monitored in the
headphone with the fader set to the left side and
u CROSS FADER PGM2 will be monitored in the head phone with the
When the input level of PGM1 and PGM2 are fader set to the rigth side. When the fader is set in
properly set, PGM1 will be heard with the cross the center, both programs will be monitored in
fader set to the left side. PGM2 will be heard the head phone.
with the cross fader set to the right side. When the
cross fader is set in the center, both programs !3 MIC LEVEL
will be heard. This is a detachable fader for the Adjusts the input level from all microphone
ease of replacement with "CF-RUS" "CF-R" or inputs.
"CF-PCV" when it is worn out.

5
 How to change the fader unit.
■HOW TO REMOVE THE TOP PANEL driver

○
1 Remove all fader knobs and the 4screws which
fix the top panel.(see fig.A)
○
2 Remove the top panel.

■HOW TO CHANGE THE FADER UNIT

○
1 Remove the screws on the fader panel.(see fig.B)
○
2 Remove the fader unit from position in mixer.
○
3 Carefully remove the multi-cable connector from
fader unit.(see fig.C)
○
4 Attach multi-cable connector to new fader unit.
○
5 Position the fader unit carefully and secure with
screws.

Remove the multi-cable

マルチケーブル
connector from fader unit.
コネクターを抜く
fig.A

driver

角4点のネジを外す。 fig.C
Remove four scews.

You can replace the CF unit with "CF-RUS",

"CF-R" or "CF-PCV".

■HOW TO REPLACE THE CF UNIT WITH "CF-PCV"

When the fader unit is replaced, please see fig.C.
Place the fader unit in the proper position and fix it
with two screws.(fig.D-○
b)

fig.B
CAUTION
There is a swith for "CF-PCV" unit. When "CF-
PCV" unit is installed, set the switch to "PCV"
mode.

CAUTION
When the fader unit is replaced, do not loosen
the screws with marking.

fig.D CF-RUS or CF-R

CF-PCV

6
 REAR PANEL
19 18 17

RISK OF ELECTRIC
SHOCK. DO NOT OPEN

WARNING;SHOCK HAZARD-DO NOT OPEN.

AVIS;RISQUE DE CHOC ELELCTRIQUE -NE PAS OUVRIR.

MADE IN CHINA UNDER LICENCE OF VESTAX TOKYO, JAPAN OUTPUT PGM 2 PGM 1 MIC
REC LINE 2 LINE 1
SERIAL NO.

DC IN LINE PHONO 2 PHONO 1

POWER
R L R L R L
DC15V
GND

14 15 16 20

!4 POWER SWITCH !8 INPUT JACK 2

The POWER LED that is located on the top Used for PGM2 input. Connect as for !7.
panel is lit when on. !9 OUTPUT JACK
!5 DC IN Connect to the input of a power amplifier. You
Connect to the DC-15 AC adapter. can also use another LINE OUT when you need
!6 GND TERMINAL to have an output besides the main output.
Connect this terminal to the ground lead of the @0 MIC INPUT JACK
turntable. This helps to reduce noise and hum. Input jacks of connection of a microphone.
!7 INPUT JACK 1
Used for PGM1 input. Connect turntable
equipped with a MM pickup cartridge to PHONO
input. CD players, tape decks, DATs, MDs etc.,
should be connected to LINE input. Line level
musical instruments with stereo outputs such as
Rhythm Machines or Samplers should also be
connected to line inputs.

7
S P E C I F I C AT I O N S
NOMINAL INPUT IMPEDANCE
INPUT SECTION PHONO 1, 2（RCA PIN JACK） -42dBv 470KΩ

LINE 1, 2  （RCA PIN JACK） -10dBv 470KΩ

MIC   （1/4" PHONE JACK） -54dBv 3.3KΩ
NOMINAL OUTPUT IMPEDANCE
OUTPUT LINE OUT   （RCA JACK） 0dBv 220Ω
SECTION
MAXIMUM OUTPUT IMPEDANCE
HEADPHONE（1/4" PHONE JACK） 70mW（47Ωload） ＞8Ω
FREQUENCY RESPONSE 20Hz ∼ 20KHz
CROSS TALK ＞100dB
S/N RATIO ＜-82dB
POWER SUPPLY DC15V 500mA
DIMENSIONS
（W×H×D） 248×105×261
（mm）
WEIGHT 3.5kg

Vestax Corporation MAY.2002 PCV002E q

 NJM4556L C38 C54 C55
3

8
10k

1
1 R175 3 U2A

1
2 1 EQ HI +Vcc
10k

3
173 473 272 272 2

2
1
1
C28

4
R124 PHONE PGM1 Lch

2
0K C27 C111 R110 NJM082L 2 R92
10u/16 10u/16 12K VR6A 4.7K
15K

2
2
1/2VP1 1/2VP1 20KC*2 C115 POWER LED

1
7
C127 C135 22P 1/2VP1 1/2VP1
R61

2
+Vcc R122 R149 1/2VP1
100u/10 100u/10 CN4J H4C 15K 100K C40 C56 68P LED11
56K 473 272 R63 SLR
1 1 1/2VP1 INPUT
R196 C39 C70 C71
U9B 2 2 1/2VP2 +Vcc U2B U3B
R103 R111 R112 22K

1
5 NJM4556L 3 3 TRIM C16 5 5

8
R59

1
7 R195 100 2 1 2 U14A 7 7 EQ MID +Vcc C18
1.5K 12K 12K

1
3
3
6 3P CON H 1 473 123 123 6 6 10u/16

8
100 3P CON S 22K
191 10u/16 3 C72 2 U15A INPUT
R125

2
1
1
C131 2 NJM082L R143 NJM082L 123 NJM082L 2 1 1 2 IC1

2
0K C130 1/2VP1 22K 3 LEVEL BA6137
15K

3
10u/16 10u/16 VR1A NJM082L

2
2
1
7
1
7
10KA*2 1/2VP1 1/2VP1 VR7A 1/2VP1
C136 C137 1/2VP1 20KC*2 2 JUMPER R15 R23

1
2
3
4
5
6
7
8
9
C41 C57 WIRE A
R57 473 272 47K 27K
470u/6.3 470u/6.3 +Vcc VR2A (2P)

1
7
1K 20KA*2

8
R53 R123 R155 R156 3 U3A
1

470 15K 120K 120K 1 EQ LOW

3
2 R89 C103
C73 R176 R177 R178 R179 R180 10K +Vcc

4
R126
2

1 SW1A 123 NJM082L 2 4.7K 4.7K 4.7K 4.7K 4.7K 10u/16

2 LBC22B-17銀 VR8A 15K

1
1
1
1
1

+Vcc 3 20KC*2 R90

1
7
U1A PHONO 1/2VP1 1/2VP1 47

8
3 C14 ↑ 1/2VP1
1 1 2 R104 R14

2
2
2
2
2
1

2 4 ↓ LINE 1.5K 47K

NJM4580L 10u/16 R11 5 C112 +Vcc R94 C105

4
C42 C58 C59 LED1 LED2 LED3 LED4 LED5 100u/16
47K 6 SW1B

8
100K
2

LBC22B-17銀 3 U4A C106 SLR SLR SLR SLR SLR

R49 R3 22P 1 EQ HI 1 2
R62

6
820K 68K R54 473 272 272 2
PHONE PGM1 Rch R95
470 10u/16 R88 IC2

4
56K R113 NJM082L R129 15K
5 BA6137
C17 12K 100K
U14B VR6B 15K
2 1 R60 6 1/2VP1 1/2VP1 20KC*2
0 C34

6
4
8
7 1/2VP1 1/2VP1

INPUT SW
392 122 22K C116
1
2
3
4
5
6
7
8
9

10u/16 5 R127 R150 1/2VP1

5 15K 100K C44 C60
1/2VP1 NJM082L 473 272 68P
C43 C74 C75 R64
U4B U5B
R105 R114 R115

4
8
1

VR1B 5 5 22K
10KA*2 7 1.5K 12K 12K 7 EQ MID C19 R91 C104

6
473 123 123 6 6 U15B 10u/16 R181 R182 R183 R184 R185 10K
2

U1B C76 6 4.7K 4.7K 4.7K 4.7K 4.7K 10u/16

5 C15 R58 R144 NJM082L 123 NJM082L 5 R130 7 1 2
1
1
1
1
1

7 1 2 1K 22K 5
15K

6
6

4
8
10u/16 R12 1/2VP1 1/2VP1 1/2VP1 NJM082L
NJM4580L 47K 1/2VP1 VR7B VR2B 5 JUMPER R16 R24
2
2
2
2
2

C45 C61 20KC*2 20KA*2 WIRE A

R50 R4 473 272 47K 27K
+Vcc (2P)

4
8
LED6 LED7 LED8 LED9 LED10

8
820K 68K R128 R157 R158 SLR SLR SLR SLR SLR
3 U5A
15K 120K 120K 1 EQ LOW C107

6
2 1 2
C77 R96

4
1 C35 123 NJM082L R131 10u/16 R93
392 122 VR8B 5 100K
20KC*2 15K 15K
R97

4
8
100K
1/2VP1

1
H01C

GND POINT

5P CON H
1/2VP2 1/2VP2

H5C
1
R106 R35 2 C123
1.5K 47K

8P CON S
8P CON H
3

CN1J
H1C
C125
1 1 +Vcc 4
C46 C62 C63
2 2 5 5P

8
3 3 3 U10A R73 MASTER MASTER 10P
4 4 1 EQ HI R77
220K

3
5 5 473 272 272 2 BALANCE LEVEL 100K
6 6 +Vcc

4
7 7 R116 NJM082L VR9A 2 R135 C86
8

8 8 C113 12K 20KC*2 2 1 2 U18A C87 C90

8

15K R75
1/2VP2 1/2VP2 C117 1 1 2 2 1 2 U19A
PHONE PGM2 Lch

1
7
4
8
3

1/2VP2 1/2VP2 10u/16 3 1 1

R133 R153 10K
22P 1/2VP2 +Vcc 10u/16 10u/16 3
4

INPUT R69 15K 100K C48 C64 68P NJM2068L 5 2

4

473 272 R71 ㊧ NJM2068L

56K C47 C78 C79
TRIM +Vcc U10B U11B 22K
R107 R117 R118
6
1
7

C22 5 5 ↑

8
2 1 R67 2 U16A 7 7 EQ MID +Vcc C24
1.5K 12K 12K

3
3
C134

1 473 123 123 6 6

100u/16

10u/16 H2C CN2J

8
22K C80
10u/16 3 2 U17A INPUT 1 1
R136
1

2 NJM082L R147 NJM082L 123 NJM082L 2 1 1 2 VR14B VR15A 2 2

4
1/2VP2 22K 3 LEVEL 10KAC*2 20KA*2 3 3
15K
3
NJM082L C124 (A curve)

1
7
1
7
2

1/2VP2 1/2VP2 VR10A 1/2VP2

1/2VP2 20KC*2 2 R21 R25
R187 100K R186 100K

VR3A 5P GND2 3P CON H 3P CON S C126

10KA*2 C49 C65 R74
473 272 47K 27K
+Vcc VR4A 10P
220K R78
1
7

20KA*2 VR14A VR15B

8
R55 R65 R134 R159 R160 3 U11A 10KAC*2 20KA*2
470 1K C88 100K
15K 120K 120K 1 EQ LOW U18B (C curve)

3
2 2 1 6 C89 C91
C81 7 1 2 2 1 R76 6 U19B

4
R137
3
6

1 SW2A 123 NJM082L 2 10u/16 5 7

10K
+Vcc 2 LBC22B-17銀 10u/16 10u/16 5
15K
U6A 3 NJM2068L 2 5 NJM2068

8
1
7
3 C20 PHONO 1/2VP2 1/2VP2 VR11A
1 1 2 ↑ 1/2VP2 20KC*2 ↓
1
7
4
8

2 R108 R36
NJM4580L 10u/16 R19 4 ↓ LINE 1.5K 47K ㊧

4
47K 5 C114 C50 C66 C67 +Vcc
6 SW2B

8
R51 R7 LBC22B-17銀 3 U12A
22P 1 EQ HI
820K 68K R70
6
R56 473 272 272 2
470

4
56K R119 NJM082L R140
VR9B 5
C23 U16B 12K 20KC*2
2 C36 R68 15K
2 1 6 1/2VP2 1/2VP2

INPUT SW
392 122

6
4
8

22K 7 1/2VP2 1/2VP2 C118

R138 R154 PHONE PGM2 Rch
10u/16 5 1/2VP2
5 15K 100K C52 C68
1/2VP2 NJM082L 473 272 68P
C51 C82 C83 R72
U12B U13B
R109 R120 R121

4
8
VR3B 5 5 H7C
10KA*2 22K C25
7 1.5K 12K 12K 7 EQ MID 1
6
1

U6B 473 123 123 6 6 U17B 10u/16 2

5 C21 R66 C84 6 C132
7 1 2 1K R148 NJM082L 123 NJM082L 5 R141 7 1 2 2P CON H 100u/25
2

6 22K 5
15K
6

10u/16 R20
R31 R27
4
8

NJM4580L 47K 1/2VP2 1/2VP2 1/2VP2 NJM082L

R22 R26 PHONE PGM1 Lch
1/2VP2 VR10B 5 22K
R52 R8 C53 C69 20KC*2 47K
VR4B 47K 27K ㊨↑ MONITOR
1
7

473 272 +Vcc 20KA*2 R151

820K 68K
4
8

8 LEVEL 100K
R139 R161 R162 3 U13A VR13A 2 C96
8

15K 120K 120K 1 EQ LOW 50KB*2 2 1 3 U7A C108

R167
6

2 1 1 2
3 C37
3

392 122 C85 2 1u/50 R100 2

4

123 R142 47
NJM082L 5 ㊧ 100K 220u/10
4

R32 ↓ R28 VR5A NJM4556L

15K PHONE PGM2 Lch
1
7

22K 47K 10KA*2 R79

R81
4
8

1K
1/2VP2
330K
1

+Vcc +Vcc VR11B

C98

+Vcc 20KC*2 CF MONITOR C121

2
22u/10

10P
R171
470K MIC R83
470K U8B R86

8
3 U8A C101 LEVEL C102 5 C29 R33 R29
27K PHONE PGM1 Rch
1 1 2 2 1 7 1 2 22K 47K

3
R188 2 6 ㊨↑
R87

5
4
8

470K 10u/16 10u/16 R189 10u/16 R152

4
NJM2068L 2 470K NJM2068L VR13B 100K
R172 R84 27K C97
50KB*2 5 U7B

4
6

4.7K VR16 18K 2 1 5 C109

R170 R85 R168
1
10KA 7 1 2

1
1
6

100K 56K 5 1u/50 R101 6 47

㊧ 100K 220u/10
C26 C100 C129 R34 R30

CN6J
2P CON S
H6C
2P CON H
C119 C120 PHONE PGM2 Rch
↓ VR5B NJM4556L
10u/16

2
2
4
8

2 1 1 1 47u/16 22K 10KA*2 R80

47K
 1 2 3 4 5 6 7 8 9 10 11 12

JACK PCB 2
Q1
2SC1627
1 R194
+VM

470

1
R193
5.6K C139
470u/25 TO PHONES

2
CN7J

1
C138 1
2

2
470u/25 +Vcc 2P CON S
DC15 1/2VP1 1/2VP1 CONTROL PCB
(500mA only) 放熱板 R102 R13
D S1 1.5K 47K D
SDDL U9A R190 +Vcc
R174 C38 C54 C55

8
J6 2 2 1 1 U20 3 3 NJM4556L 10k
R175

8
3 NJM7812 10K 1 3 U2A

1
1 2 1 EQ HI +Vcc
1

1
C5 C110 R173 10k 473 272 272 2
2

3
220u/16 C28

4
2

1
4.7u/25 10K C27 R110 R124 PHONE PGM1 Lch

4
C111 NJM082L 2 R92
2

2
10u/16 10u/16 12K VR6A 4.7K
15K
HEC0470-01-630 1/2VP1 1/2VP1 20KC*2 C115 POWER LED

2
C127 C135 22P 1/2VP1 1/2VP1

7
GND +Vcc R61 R122 R149 1/2VP1

2
GND1 100u/10 100u/10 CN4J H4C 56K
15K 100K C40 C56
R63
68P LED11
1 1 1/2VP1 INPUT C39 C70 C71
473 272 SLR
U9B R196 2 2 1/2VP2 +Vcc U2B U3B
R103 R111 R112 22K
R192 5 NJM4556L 3 3 TRIM C16 5 5

1
R195 100 R59 EQ MID C18

8
10K 7 2 1 2 U14A 7 1.5K 12K 12K 7 +Vcc

1
6 3P CON S 3P CON H 22K 1 473 123 123 6 6 10u/16

3
100 C72 INPUT

8
R191 10u/16 3 2 U15A
2 C131 2 NJM082L R143 NJM082L 123 NJM082L 2 R125 1 1 2 IC1

1
10K 22K LEVEL

4
C130 1/2VP1 3 BA6137

2
15K
10u/16 10u/16 VR1A NJM082L

3
4
10KA*2 1/2VP1 1/2VP1 VR7A 1/2VP1

7
C136 C137 1/2VP1 20KC*2 2 JUMPER R15 R23
C41 C57 WIRE A

9
R57 473 272 47K 27K
470u/6.3 470u/6.3 +Vcc VR2A (2P)
1K 20KA*2

7
R123 R155 R156

8
R53 3 U3A
470 15K 120K 120K 1 EQ LOW

1
2 R89 C103

3
C73 R176 R177 R178 R179 R180 10K +Vcc
123 R126 4.7K 4.7K 4.7K 4.7K 4.7K 10u/16

4
1 SW1A NJM082L 2

2
R41 2 LBC22B-17銀 VR8A 15K
J1A 56K +Vcc 3 20KC*2 R90

1
T5857AAAF C1 U1A PHONO 47
↑
1/2VP1 1/2VP1

7
R37 C14
8

2 2 1 3 1/2VP1
R104 R14
↓ LINE
1 1 2
1K 1.5K 47K
1u/50 2 4
1

1
R1 NJM4580L 10u/16 R11 5 C112 +Vcc R94 C105
C42 C58 C59 LED1 LED2 LED3 LED4 LED5 100u/16
4

390K C10 R45 47K 6 SW1B 100K C106 SLR SLR SLR SLR SLR

8
22P 1.5K LBC22B-17銀 3 U4A

2
R49 R3 22P 1 EQ HI 1 2
R54 R62 473 272 272 2

6
INPUT SW
820K 68K R95
33u/25

PHONE PGM1 Rch

470 10u/16 R88 IC2
1

56K R113 R129

4
NJM082L 5
100K 15K BA6137
C17 12K
C6

U14B VR6B 15K

2 1 R60 6 1/2VP1 1/2VP1 20KC*2
2

C30 C34
PHONO1 (-46dB) 392 122 22K 7 1/2VP1 1/2VP1 C116

8
10u/16 5 R127 R150 1/2VP1

9
5 15K 100K C44 C60
1/2VP1 NJM082L 473 272 68P
C43 C74 C75 R64
U4B U5B
VR1B 5 R105 R114 R115 5

1
22K
R42 10KA*2 7 1.5K 12K 12K 7 EQ MID C19 R91 C104
J1C 56K 473 123 123 6 6 U15B 10u/16 R181 R182 R183 R184 R185 10K

6
T5857AAAF C2 U1B C76 6 4.7K 4.7K 4.7K 4.7K 4.7K 10u/16

2
C 5 2 1 R38 5 C15 R58 R144 NJM082L 123 NJM082L 5 R130 7 1 2 C
7 1 2 1K 22K 5

1
1K 15K
1u/50 6
4

6
R2 10u/16 R12 1/2VP1 1/2VP1 1/2VP1 NJM082L

8
PGM1 390K C11 R46 NJM4580L 47K 1/2VP1 VR7B VR2B 5 JUMPER R16 R24
22P 1.5K C45 C61 20KC*2 20KA*2 WIRE A

2
R50 R4 473 272 47K 27K
+Vcc (2P)
LED6 LED7 LED8 LED9 LED10

8
820K 68K R128 R157 R158
33u/25

SLR SLR SLR SLR SLR

8
3 U5A
1

15K 120K 120K 1 EQ LOW C107

C7

2 1 2

6
C77 R96
2

C31 C35 123 R131

4
392 122 NJM082L VR8B 5 100K 10u/16 R93
20KC*2 15K 15K
J1B R97
T5857AAAF

8
100K
3 1/2VP1

5P CON H
H01C

1
R9
1

47K GND POINT

H5C
8P CON S

8P CON H

1/2VP2 1/2VP2
1
LINE1(-10dB) R106 R35
CN1J

2 C123
H1C

1.5K 47K 3 C125

1 1 +Vcc 4
C46 C62 C63
J1D 2 2 5 5P
R73 MASTER MASTER

8
T5857AAAF 3 3 3 U10A 10P
6 4 4 1 EQ HI R77 +VM J3A
220K
5 5 473 272 272 2 BALANCE LEVEL T5857AAAF OUTPUT1

3
R10 100K R163
6 6 +Vcc 2
4

R116 R135 C86 (0dB)

4
47K 7 7 NJM082L VR9A 2
220
12K C87 C90

8
8 8 C113 20KC*2 2 1 2 U18A

1
15K R75 C92

8
1/2VP2 1/2VP2 C117 PHONE PGM2 Lch
1 1 2 2 1 2 U19A
1/2VP2 1/2VP2 10u/16 3 1 1 2

3
R133 R153 10K
22P 1/2VP2 +Vcc 10u/16 10u/16 3
INPUT R69 15K 100K C48 C64

4
68P NJM2068L 5 2 10u/16
473 272 R71 ㊧

4
NJM2068L

R187 100K R186 100K

56K C47 C78 C79 R98 J3B
TRIM U10B U11B T5857AAAF
↑ 100K

100u/16
+Vcc 22K
C22 5 R107 R117 R118 5 C133 R164 3

7
R67 EQ MID C24 100u/16

C134
8

2 1 2 U16A 7 1.5K 12K 12K 7 +Vcc

220
22K 1 473 123 123 6 6 10u/16 H2C CN2J
3

1
C80 INPUT

8
10u/16 3 2 U17A 1 1 R99
2 NJM082L R147 NJM082L 123 NJM082L 2 R136 1 1 2 VR14B VR15A 2 2 100K

1
22K LEVEL
4

1/2VP2 3 10KAC*2 20KA*2 3 3

2
15K
NJM082L C124 (A curve)

3
4
1/2VP2 1/2VP2 VR10A 1/2VP2
1

2
VR3A 1/2VP2 20KC*2 2 R21 R25 5P GND2 3P CON H 3P CON S C126
10KA*2 C49 C65 R74
473 272 47K 27K
+Vcc VR4A 220K 10P J3C
20KA*2 VR14A VR15B R78 T5857AAAF

7
R65 R134 R159 R160 R165 OUTPUT2

8
R55 3 U11A 10KAC*2 20KA*2 100K 5
470 1K
15K 120K 120K 1 EQ LOW C88 U18B (C curve) 220
2 2 1 6 C89 C91 (0dB)

4
C81 7 1 2 2 1 R76 6 U19B C93
123 R137

4
R43 1 SW2A NJM082L 2 10u/16 5 7 1 2

6
56K 10K
B J2A +Vcc 2 LBC22B-17銀 15K 10u/16 10u/16 5 B
T5857AAAF C3 U6A 3 NJM2068L 2 5 NJM2068L 10u/16
R39 C20
8

PHONO VR11A J3D

↑ ↓
2 2 1 3 1/2VP2 1/2VP2

7
1K 1 1 2 1/2VP2 20KC*2 T5857AAAF
1u/50 R108 R36 R166
↓ LINE
2 6
1

8
R5 NJM4580L 10u/16 R19 4 1.5K 47K ㊧ 220
4

390K C12 R47 47K 5 C114 +Vcc

4
22P 1.5K C50 C66 C67
6 SW2B
R51 R7
8

LBC22B-17銀 3 U12A
22P 1 EQ HI
INPUT SW

820K 68K R56 R70 473 272 272 2

1

6
33u/25

470 56K R119 R140

C8

NJM082L VR9B 5
C23 U16B 12K 20KC*2
2

C32 C36 R68 15K

PHONO2 (-46dB) 392 122 2 1 6 1/2VP2 1/2VP2
22K 7 1/2VP2 1/2VP2 C118
6

8
10u/16 5 R138 R154 1/2VP2
PHONE PGM2 Rch
5 15K 100K C52 C68
1/2VP2 NJM082L 473 272 68P
C51 C82 C83 R72
U12B U13B
R44 VR3B 5 R109 R120 R121 5 H7C
4

22K
J2C 56K 10KA*2 7 1.5K 12K 12K 7 EQ MID C25 1
T5857AAAF C4 U6B 473 123 123 6 6 U17B 10u/16 2

1
5 2 1 R40 5 C21 R66 C84 6 C132
7 1 2 1K R148 NJM082L 123 NJM082L 5 R141 7 1 2 2P CON H 100u/25
1K 22K
1u/50 6 5
4

2
R6 R20 15K
10u/16

6
390K C13 R48 NJM4580L 47K 1/2VP2 1/2VP2 1/2VP2 NJM082L R31 R27
4

22P 1.5K VR10B R22 R26 PHONE PGM1 Lch

㊨↑
1/2VP2 5 22K
R52 R8 47K
PGM2 C53 C69 20KC*2 VR4B 47K 27K MONITOR
473 272 +Vcc 20KA*2 R151
PHONES PCB

7
820K 68K
LEVEL 100K
1

8
R139 R161 R162
33u/25

C96
8

3 U13A VR13A 2
EQ LOW C108
C9

8
15K 120K 120K 1 50KB*2 2 1 3 U7A

3
2 1 R167 1 2
2

C33 C37 C85 R100

392 122 2 1u/50 2 47

3
123 R142 ㊧ R145
4

NJM082L 100K 220u/10

↓
5
R32 R28 22K

4
J2B 15K PHONE PGM2 Lch
VR5A NJM4556L
T5857AAAF 22K 10KA*2 R79

7
47K R81

3P CON H

3P CON S
3 1K
4

1/2VP2
330K
R17 MONITOR OUT

CN3P
1

H3C
22u/10
47K VR11B

C98
+Vcc +Vcc
+Vcc 20KC*2 CF MONITOR C121 1 1 2
LINE2(0dB) 10P 2 2 3

2
R171 3 3 1
470K MIC R83
R86 J4A
J2D 470K U8B
C101 LEVEL C102 C29 R33 R29
8

T5857AAAF 3 U8A 5 27K HLJ0546-01-010

PHONE PGM1 Rch
㊨↑
6 1 1 2 2 1 7 1 2 22K
R188 47K
2 6
3

R18 470K 10u/16 10u/16 R189 10u/16 R87 R152

4

8
470K
4

47K NJM2068L 2 NJM2068L 27K VR13B 100K

R172 R84 50KB*2 5 C97 U7B
4.7K VR16 18K 2 1 5 C109
4

6
R170 R85 R168
2P CON S

2P CON H

10KA 7 1 2
1

100K 5 1u/50 R101 6 47

1

6
A 56K A
㊧ 100K
CN6J

220u/10 R146
↓
H6C

C26 C100 C119 C129 C120 R34 R30 VR5B NJM4556L 22K
J5 2 R169 2 1 1 1 10u/16 47u/16 PHONE PGM2 Rch
10KA*2 R80
22K
2

8
47K R82
MIC IN 4 100 2 2 10P 22P 1K
1 10u/16 330K

1
22u/10
HLJ0546-01-110 C128 R132 C122

C99
22p 3.3k
MIC JACK 10P

2
（金属JACK+PLASTIC BUSH）

Title

PCV-002U 量産図
改訂 2002.1.7 Size Number Revision
(R88、R93 ∼ 27K→15K)
(C132 ∼ 100u/16→100u/25)
A1
2001.11.20
Date: 7-Jan-2002 Sheet of
File: D:\Vestax\..\PCV002—ÊŽY•}.asc Drawn By: AIMI
1 2 3 4 5 6 7 8 9 10 11 12
 C123
C125
5P
R73 MASTER MASTER 10P
R77 +VM J3A
220K
BALANCE LEVEL 100K R163
T5857AAAF OUTPUT1
+Vcc 2
C86
220 (0dB)
8

2 1 2 U18A C87 C90

1
R75

8
1 1 2 2 1 2 U19A C92
10u/16 3 1 1 2
4

3
10K
+Vcc 10u/16 10u/16 3
4

NJM2068L 5 2 10u/16

4
㊧
R187 100K R186 100K

NJM2068L R98 J3B

T5857AAAF
100u/16

100K
↑ C133 R164 3
6

7 100u/16
C134

220
H2C CN2J

1
1 1 R99
VR14B VR15A 2 2 100K
1

10KAC*2 20KA*2 3 3

2
C124 (A curve)
2

R74
5P GND2 3P CON H 3P CON S C126

220K 10P J3C

VR14A VR15B R78 T5857AAAF
10KAC*2 20KA*2 R165 5 OUTPUT2
C88 100K
U18B (C curve) 220
2 1 6 C89 C91 (0dB)

4
7 1 2 2 1 R76 6 U19B C93
10u/16 5 7 1 2
3

10K
10u/16 10u/16 5 B
NJM2068L 2 5 NJM2068L 10u/16
J3D
↓ R166
T5857AAAF
6
1

㊧ 220

4
H7C
1
2
1

C132
2P CON H 100u/25
2

R31 R27
26 PHONE PGM1 Lch
22K
7K ㊨↑ 47K
MONITOR
R151
PHONES PCB
1

LEVEL 100K
VR13A 2 C96
8

50KB*2 2 1 3 U7A C108

3

1 R167 1 2
2 1u/50 R100 2
3

47
㊧ 100K 220u/10 R145
R32 ↓ R28 22K
4

PHONE PGM2 Lch

VR5A NJM4556L
10KA*2 R79
1

22K 47K R81

3P CON H

3P CON S

1K
330K
MONITOR OUT
CN3P
1

H3C
22u/10
C98

CF MONITOR C121 1 1 2
10P 2 2 3
2

3 3 1
J4A
R33 R29 HLJ0546-01-010
PHONE PGM1 Rch
22K
㊨↑ 47K
R152
4

VR13B 100K
50KB*2 5 C97 U7B
2 1 5 C109
6

7 R168 1 2
5 1u/50 R101 6
6

47 A
㊧ 100K 220u/10 R146
PHONE PGM2 Rch
R34 ↓ R30 VR5B NJM4556L 22K
10KA*2 R80
4

22K 47K R82

1K
330K
1
22u/10

C122
C99

10P
2

Title

Output, Phones 改訂 2002.1.7

(R88、R93 ∼ 27K→15K)
Size
A1
Number
PCV-002U 量産図
Revision

(C132 ∼ 100u/16→100u/25) 2001.11.20

Date: 7-Jan-2002 Sheet of
File: D:\Vestax\..\PCV002—ÊŽ Y• }.asc Drawn By: AIMI
9 10 11 12
 1 2 3 4

JACK PCB 2
Q1
2SC1627
1 R194
+VM

470

1
R193
5.6K C139
470u/25 TO PHONES

2
CN7J
1 C138 1
2
2

470u/25 +Vcc 2P CON S

DC15
(500mA only) 放熱板
D S1
SDDL U9A R190
R174

8
J6 2 2 1 1 U20 3 3 NJM4556L 10k
3 NJM7812 1 R175
1

10K

1
1 2
1

1
C5 C110 R173 10k
2

220u/16 C28

4
2

1
4.7u/25 10K C27
2

2
10u/16 10u/16
HEC0470-01-630

2
C127 C135
GND +Vcc
GND1 100u/10 100u/10 CN4J H4C
1 1 1/2VP1
U9B R196 2 2 1/2VP2
R192 5 NJM4556L 3 3
10K 7 R195 100
1

6 3P CON S 3P CON H

1
R191 100
C131
2

1
10K C130

2
10u/16 10u/16

2
C136 C137
470u/6.3 470u/6.3
R5
47

1
R41
J1A 56K +Vcc 3
T5857AAAF C1 U1A
R37 ↑
8

2 2 1 3 C14
1 1 2
1u/50
1K
2 4 ↓
1

R1 NJM4580L 10u/16 R11

4

390K C10 R45 47K 6

22P 1.5K
R49 R3

INPUT SW
820K 68K
33u/25
1
C6
2

C30 C34
PHONO1 (-46dB) 392 122

R42
J1C 56K
T5857AAAF C2 U1B
C 5 2 1 R38 5 C15
7 1 2
1K
1u/50 6
4

R2 10u/16 R12
PGM1 390K C11 R46 NJM4580L 47K
22P 1.5K
R50 R4
820K 68K
33u/25
1
C7
2

C31 C35
392 122
J1B
T5857AAAF
3

R9
1

47K
8P CON S

8P CON H

LINE1(-10dB)
CN1J

H1C

1 1
J1D 2 2
T5857AAAF 3 3
6 4 4
5 5
R10 6 6
4

47K 7 7

Input +Power
8 8
 5P C
GND POINT

H5C
8P CON H

1/2VP2 1/2VP2
1
R106 R35 2
H1C

1.5K 47K 3
1 +Vcc 4
C46 C62 C63
2 5

8
3 3 U10A
4 1 EQ HI
5 473 272 272 2

3
6
R135

4
7 R116 NJM082L VR9A 2
8 C113 12K 20KC*2 15K
1/2VP2 1/2VP2 C117 PHONE PGM2 Lch
1/2VP2 1/2VP2

7
22P R133 R153 1/2VP2
INPUT R69 15K 100K C48 C64 68P
473 272 R71
56K C47 C78 C79
TRIM +Vcc U10B
R107 R117 R118
U11B 22K
C22 5 5
R67
8

2 1 2 U16A 7 1.5K 12K 12K 7 EQ MID +Vcc C24

1 473 123 123 6 6 10u/16
3

3
22K
INPUT

8
10u/16 3 C80 2 U17A
2 NJM082L R147 NJM082L 123 NJM082L 2 R136 1 1 2
4

1/2VP2 22K 3 LEVEL

15K
NJM082L

3
4
1/2VP2 1/2VP2 VR10A 1/2VP2
1

7
VR3A 1/2VP2 20KC*2 2 R21
10KA*2 C49 C65
473 272 47K
+Vcc VR4A
20KA*2

7
R134 R159 R160

8
R55 R65 3 U11A
470 1K 1 EQ LOW
15K 120K 120K
2

3
C81
123 R137
4
1 SW2A NJM082L 2
2 LBC22B-17銀 15K
3
PHONO 1/2VP2 1/2VP2 VR11A

7
↑ R108 R36
1/2VP2 20KC*2
4 ↓ LINE 1.5K 47K
5 C114 C50 C66 C67 +Vcc
6 SW2B
8

LBC22B-17銀 3 U12A
22P 1 EQ HI
INPUT SW

R56 R70 473 272 272 2

6
470 56K R140
4

R119 NJM082L VR9B 5

C23 U16B 12K 20KC*2
R68 15K
2 1 6 1/2VP2 1/2VP2
7 1/2VP2 1/2VP2 C118
6

8
22K R138 R154 PHONE PGM2 Rch
10u/16 5 1/2VP2
5 15K 100K C52 C68
1/2VP2 NJM082L 473 272 68P
C51 C82 C83 R72
U12B U13B
VR3B 5 R109 R120 R121 5
4

22K
10KA*2 7 1.5K 12K 12K 7 EQ MID C25
473 123 123 6 6 U17B 10u/16
6

R66 C84 6
1K R148 NJM082L 123 NJM082L 5 R141 7 1 2
22K 5
15K

6
1/2VP2 1/2VP2 1/2VP2 NJM082L
4

1/2VP2 VR10B 5 R22

C53 C69 20KC*2 VR4B
473 272 47K
+Vcc 20KA*2

8
R139 R161 R162
8

3 U13A
15K 120K 120K 1 EQ LOW
2
6

C85
123 R142
4

NJM082L 5
15K
4

1/2VP2

+Vcc +Vcc VR11B

+Vcc 20KC*2
R171
470K MIC R83
470K U8B R86
LEVEL
8

3 U8A C101 C102 5 C29

27K
1 1 2 2 1 7 1 2
R188 2 6
3

470K 10u/16 10u/16 R189 10u/16 R87

5

470K
4

NJM2068L 2 NJM2068L 27K

R172 R84
4.7K VR16 18K
4

R170 R85
2P CON H

10KA
1
1

100K 56K
H6C

C100 C119 C129 C120

1 10u/16 47u/16
2

2 10P 22P

Mic; Channel EQ

4 5 6 7 8
 9 10 11 12

CONTROL PCB
D

+Vcc

R92
4.7K
POWER LED
2

LED11
SLR
1

IC1
BA6137

R23
1

27K
1

R89 C103
R176 R177 R178 R179 R180 10K +Vcc
4.7K 4.7K 4.7K 4.7K 4.7K 10u/16
2

R90
1

47
2

R94 C105
LED1 LED2 LED3 LED4 LED5 100u/16
100K C106 SLR SLR SLR SLR SLR
2

1 2
R95 10u/16 R88 IC2
100K 15K BA6137
1

9
1

R91 C104
R181 R182 R183 R184 R185 10K
4.7K 4.7K 4.7K 4.7K 4.7K 10u/16
2

C
1

R24
2

27K
LED6 LED7 LED8 LED9 LED10
SLR SLR SLR SLR SLR
C107
1 2
R96
100K 10u/16 R93
15K
R97
100K

LED Control
C123
C125
K02100DD02 PCV-002 CONNECTOR RO/KNOB(SMALL)SILVER ALL
H030100100 PCV-002 CASE RUBBER STAND FOOT
K013000002 PCV-002 Knob SL/KNOB(LARGE)SILVER IF, CF
K011000002 PCV-002 Knob SL/KNOB(SMALL)SILVER CF MONITOR
B020100200 PCV-002 CASE SUB FRAME
T021627A00 PCV-002 TRANSISTOR TR 2SC1627A In-Out Q1 1
V0209L1204 PCV-002 VR TRIM VOLUME Control VR1 VR3 1 10KA*2 L=15mm RK09L12D0