Paae 229540 SPC en

Engine Spare Parts Catalogue
CATALOGUES
Document ID DBAE577326-
Date of issue 14.09.2017
Product type W20V32GD
Product number PAAE229540

© Copyright by Wärtsilä Finland Oy
All rights reserved. No part of this booklet may be reproduced or copied in any form or by any means (electronic,
mechanical, graphic, photocopying, recording, taping or other information retrieval systems) without the prior written
permission of the copyright owner.
THIS PUBLICATION IS DESIGNED TO PROVIDE AN ACCURATE AND AUTHORITATIVE INFORMATION WITH
REGARD TO THE SUBJECT-MATTER COVERED AS WAS AVAILABLE AT THE TIME OF PRINTING. HOWEVER,
THE PUBLICATION DEALS WITH COMPLICATED TECHNICAL MATTERS SUITED ONLY FOR SPECIALISTS IN THE
AREA, AND THE DESIGN OF THE SUBJECT-PRODUCTS IS SUBJECT TO REGULAR IMPROVEMENTS,
MODIFICATIONS AND CHANGES. CONSEQUENTLY, THE PUBLISHER AND COPYRIGHT OWNER OF THIS
PUBLICATION CAN NOT ACCEPT ANY RESPONSIBILITY OR LIABILITY FOR ANY EVENTUAL ERRORS OR
OMISSIONS IN THIS BOOKLET OR FOR DISCREPANCIES ARISING FROM THE FEATURES OF ANY ACTUAL ITEM
IN THE RESPECTIVE PRODUCT BEING DIFFERENT FROM THOSE SHOWN IN THIS PUBLICATION. THE
PUBLISHER AND COPYRIGHT OWNER SHALL UNDER NO CIRCUMSTANCES BE HELD LIABLE FOR ANY
FINANCIAL CONSEQUENTIAL DAMAGES OR OTHER LOSS, OR ANY OTHER DAMAGE OR INJURY, SUFFERED
BY ANY PARTY MAKING USE OF THIS PUBLICATION OR THE INFORMATION CONTAINED HEREIN.
14.09.2017 Spare Parts Catalogue Wärtsilä 32
Table of contents
Product type W20V32
Product number: PAAE229540
100 Engine block, bearings, oil sump

Covers
Section Description
100-0007F Hydraulic jack for main bearing cap
100-013A Oil strainer for suction pump
100-0021E Cylinder liner with anti-polishing ring
100-0035C Grounding equipment
100-0054A Wet sump
100-0063A Engine block
107-0002F Crankcase cover with relief valve
107-0017H Casing, covers, end plates V32
107-0072C End cover
107-086A Cover for Hot-box end piece
107-0114A Heat shield for indicator valve
107-0115A Heat shield for indicator valve
107-0125C Covers in the free end
107-0161B Side covers, lower part 20V32
107-0181A Equipment for LT-water thermostat valve
107-0184A Water connections for pump cover
107-0186A Equipment for HT-water thermostat valve
107-0187C Equipment for pump cover
107-0188B Equipment for pump cover
107-0190E Pump cover
107-0191F Equipment for water pump
107-0213A Cover plate for cylinderhead cover
107-0230A Cover for cylinder head
Page 1 / 8
107-0234B Covers between cylinder heads

107-0235B Covers between cylinder heads
107-0276B Multi cover B-bank
107-0285B Covers in the flywheel end
107-0332B Side cover, lower part
107-0336A Covers
107-0388A Side cover
107-0419A Covers for air bottle
107-0532A Multicover A-bank
110 Crankshaft, flywheel

Connecting rod, piston
Section Description
110-0004F Vibration damper
110-0020A Crankshaft
111-0003B Connecting rod
113-001A Piston
114-0003D Flywheel
114-0013A Flywheel
120 Cylinder head with valves
Section Description
120-0025A Cylinder head equipment
120-0034C Cylinder head
120-0097A Cylinder head with starting valve
120-0098A Cylinder head without starting valve
121-0003B Inlet valve with rotocap
121-0004B Exhaust valve with rotocap
123-0005A Starting valve
Page 2 / 8
125-0002C Indicator valve
130 Intermediate gears
Section Description
131-0006D Bearing cover for camshaft B-bank
131-0007C Intermediate gears for camshaft drive
140 Valve mechanism, camshaft
Section Description
143-003A Rocker arms and bearing bracket
145-0001H Valve tappet with guide block
148-0053A Camshaft CWR
150 Charge air system
Section Description
156-0018H Turbocharger
156-019B Speed pickup for TC
156-0056B Vibration measurements points
156-0105B Cooling air pipe for TC impeller
156-0106A Drain pipe from receiver
156-0136C Charge air system
156-0137B Covers for air duct
156-0243A Pulsation damper
156-0285A Drain pipe in flywheel end
156-0286A Drain pipe in free end
156-0408A Drain pipe from receiver
160 Injection equipment

Gas manifold
Section Description
161-0002D Lifter for injection pump
165-0007G Injection pump
167-0011B Injection valve
167-0020A Injection valve equipment
Page 3 / 8
180 Lubricating oil pumps, thermostatic valves
Section Description
181-0018A Lubricating oil pump
181-0019B Lubricating oil pump
182-0006B Prelubricating oil pump
182-0008B Prelubricating oil pump
183-0007A Thermostatic element assembly
184-0009A Oil dipstick
190 Cooling water pumps, thermostatic valves
Section Description
191-0007F Water pump
196-008C Connection piece for water system
196-0017A Connection piece for LT-water
196-0018A Cooling water pipes
200 Exhaust manifold
Section Description
200-0037B Exhaust system
200-0038A Connection piece for exhaust gas
200-0061A Multiduct
205-0106B Insulation box
205-0157A Insulating box, connection part
210 Starting equipment
Section Description
211-0008A Starting air distributor
213-0008E Shut-down mechanism assembly
213-0020A Limit switch for stop lever
217-0005A Main starting valve
218-0013C Air block
220 Regulating mechanism
Section Description
220-0003A Booster servomotor
Page 4 / 8
220-0013B Governor
223-0015D Booster-motor
223-0029A Governor drive
224-0002B Levers for governor
224-0005F Control shaft, B bank
224-0006D Bearing support for link levers
224-0010B Control shaft, A bank
228-001C Overspeed trip device
228-0015E Overspeed trip device
228-0016B Overspeed trip device
228-0033G Air bottle
228-0035A Load limiter assembly, hot box
228-0042B Air bottle, B-Bank
350 Manifold (fuel, lube oil, cooling water, starting air etc.)
Section Description
350-0014C Cover for fuel pipes
350-0015B Pressure valve
350-0017F Bracket
350-0067C Fuel pipes in free end
350-0074C Fuel pipes in free end
350-0083A Fuel oil pipes in free end
350-0138B Fuel pipes
350-0168A Covers
350-0170C Fuel pipes
350-0173B Fuel pipe
350-0332C Fuel system
350-0352A Bracket for fuel system
352-0013D Oil nozzle for intermediate gears
352-0054B Lube oil pipes
352-0079B Oil pipe
352-0086C Pressure pipe from prelube pump
352-0087K Oil suction pipe
352-0099B Lube oil connection
352-0129C Lubricating oil pipes in flywheel end
Page 5 / 8
354-0014F LT-water pipes in flywheel end

355-0064B Air vent system, LT water
355-0084B Air vent system, HT water
355-0130C Cooling water pipes
355-0132A Air vent system from multiducts
355-0135A Air vent system from oil module
355-0171A Air vent system connection part
357-0022C Starting air pipe
357-0069A Turning device, pipes
357-0189D Starting air system
358-0009D Leak oil pipe, dirty, free end
358-0044A Connection pieces for oil pipe
358-0052B Leak oil pipe, clean, free end
358-0108A Leak fuel pipes
370 Cleaning device

Crankcase ventilation
Section Description
372-0082A Cleaning device for turbocharger
378-0013B Ventilation valve
378-0016B Crankcase breather
387-0001P Chemicals
450 Pneumatic components
Section Description
452-0101A Maintenance kit for solenoid valve
452-0102A Maintenance kit for solenoid valve
470 Filters
Coolers
Section Description
471-008A Running-in filter
471-0012C Lubricating oil filter
473-0005B Centrifugal filter
474-0007B Oil sample valve
474-0014D Fastening for lube oil module
Page 6 / 8
474-0023C Lube oil module

476-0014A Charge air cooler
476-0016D Charge air cooler assembly
480 Turning device
Section Description
482-0019A Cover for fuel oil pipes
483-0014A Turning device
483-0015C Equipment for turning device
500 Transducers, instrument panel, thermometers
Section Description
504-0026B Temperature sensor for exhaust gas
504-0104A Temperature sensor for exhaust gas
504-0121A Electrical equipment for air bottle
506-0186C Sensors for lube oil
506-0213A Sensors for control air
506-0215B Sensor for crankcase pressure
506-0239A Wiring harness for turbocharger
506-0240B Electrical equipment for turbocharger
506-0241A Sensors for multicover, B-bank
506-0247A Sensors
506-0348C Sensors for Multicover, A-bank
506-0349A Sensors on pump cover
507-0036H Main bearing temperature sensors
507-0116C Terminal box
507-0116D Terminal box
507-0181A Speed sensors
507-0206B Pressure gauge valve
507-0269B Side cover lower part, A-side
507-0270B Side cover lower part, B-side
507-0277A Speed measuring system
507-0318F Temperature measuring system for big end bearing
507-0337A Electrical equipment, A bank
507-0338A Electrical equipment, B bank
Page 7 / 8
507-0360A Temperature measuring system for big end bearing

507-0423A Adapter and test valve for pressure sensors
507-0485A Pressure gauge valve
507-0514A Wiring harness assembly for lube oil module
507-0515A Wiring harness for lube oil module
507-0591A Cable for converter, big end bearing temperature sensor system
508-0018A Oil level transducer
514-0008B Pressure gauge
516-0217A Connecting box
516-0221A Wiring harness assembly for connecting box
516-0272B Electrical equipment
600 Connecting pieces, extension shaft, electrical motors
Section Description
604-0147E Accessories for common base frame
800 Tools
Section Description
810-0001C Tools for cylinder liner
810-0002B Tools for main bearings
811-0001B Tools for piston
811-0002B Tools for connecting rod
811-0003F Hydraulic tightening tools
812-0001B Tools for cylinder head
813-0001B Tools for intermediate gear
816-0004D Tools for injection equipment
837-0001E Tools for turbocharger
886-0002C Hydraulic tool (M56)
886-0003D Hydraulic tool (M42)
886-0005B Hydraulic tool (M80)
890-0005B High pressure pump
890-0025E Miscellaneous tools
890-0032A Low pressure handpump
Page 8 / 8
Alphabetical index
Product type W20V32
Description Section
Air block 218-0013C

Air bottle 228-0033G
Air bottle, B-Bank 228-0042B
Air vent system, LT water 355-0064B
Air vent system, HT water 355-0084B
Air vent system from multiducts 355-0132A
Air vent system from oil module 355-0135A
Air vent system connection part 355-0171A
Adapter and test valve for pressure sensors 507-0423A
Accessories for common base frame 604-0147E
Description Section
Bearing cover for camshaft B-bank 131-0006D

Booster servomotor 220-0003A
Booster-motor 223-0015D
Bearing support for link levers 224-0006D
Bracket 350-0017F
Bracket for fuel system 350-0352A
Description Section
Cylinder liner with anti-polishing ring 100-0021E

Crankcase cover with relief valve 107-0002F
Casing, covers, end plates V32 107-0017H
Covers in the free end 107-0125C
Page 1 / 8
Cover plate for cylinderhead cover 107-0213A

Cover for cylinder head 107-0230A
Covers between cylinder heads 107-0234B
Covers between cylinder heads 107-0235B
Covers in the flywheel end 107-0285B
Covers 107-0336A
Covers for air bottle 107-0419A
Cover for Hot-box end piece 107-086A
Crankshaft 110-0020A
Connecting rod 111-0003B
Cylinder head equipment 120-0025A
Cylinder head 120-0034C
Cylinder head with starting valve 120-0097A
Cylinder head without starting valve 120-0098A
Camshaft CWR 148-0053A
Cooling air pipe for TC impeller 156-0105B
Charge air system 156-0136C
Covers for air duct 156-0137B
Connection piece for LT-water 196-0017A
Cooling water pipes 196-0018A
Connection piece for water system 196-008C
Connection piece for exhaust gas 200-0038A
Control shaft, B bank 224-0005F
Control shaft, A bank 224-0010B
Cover for fuel pipes 350-0014C
Covers 350-0168A
Cooling water pipes 355-0130C
Connection pieces for oil pipe 358-0044A
Cleaning device for turbocharger 372-0082A
Crankcase breather 378-0016B
Chemicals 387-0001P
Page 2 / 8
Centrifugal filter 473-0005B

Charge air cooler 476-0014A
Charge air cooler assembly 476-0016D
Cover for fuel oil pipes 482-0019A
Cable for converter, big end bearing temperature sensor system 507-0591A
Connecting box 516-0217A
Description Section
Drain pipe from receiver 156-0106A

Drain pipe in flywheel end 156-0285A
Drain pipe in free end 156-0286A
Drain pipe from receiver 156-0408A
Description Section
Engine block 100-0063A

End cover 107-0072C
Equipment for LT-water thermostat valve 107-0181A
Equipment for HT-water thermostat valve 107-0186A
Equipment for pump cover 107-0187C
Equipment for pump cover 107-0188B
Equipment for water pump 107-0191F
Exhaust valve with rotocap 121-0004B
Exhaust system 200-0037B
Equipment for turning device 483-0015C
Electrical equipment for air bottle 504-0121A
Electrical equipment for turbocharger 506-0240B
Electrical equipment, A bank 507-0337A
Electrical equipment, B bank 507-0338A
Electrical equipment 516-0272B
Description Section
Flywheel 114-0003D
Flywheel 114-0013A
Page 3 / 8
Fuel pipes in free end 350-0067C

Fuel pipes in free end 350-0074C
Fuel oil pipes in free end 350-0083A
Fuel pipes 350-0138B
Fuel pipes 350-0170C
Fuel pipe 350-0173B
Fuel system 350-0332C
Fastening for lube oil module 474-0014D
Description Section
Grounding equipment 100-0035C

Governor 220-0013B
Governor drive 223-0029A
Description Section
Hydraulic jack for main bearing cap 100-0007F

Heat shield for indicator valve 107-0114A
Heat shield for indicator valve 107-0115A
Hydraulic tightening tools 811-0003F
Hydraulic tool (M56) 886-0002C
Hydraulic tool (M42) 886-0003D
Hydraulic tool (M80) 886-0005B
High pressure pump 890-0005B
Description Section
Inlet valve with rotocap 121-0003B

Indicator valve 125-0002C
Intermediate gears for camshaft drive 131-0007C
Injection pump 165-0007G
Injection valve 167-0011B
Injection valve equipment 167-0020A
Insulation box 205-0106B
Insulating box, connection part 205-0157A
Page 4 / 8
Description Section
Lifter for injection pump 161-0002D

Lubricating oil pump 181-0018A
Lubricating oil pump 181-0019B
Limit switch for stop lever 213-0020A
Levers for governor 224-0002B
Load limiter assembly, hot box 228-0035A
Lube oil pipes 352-0054B
Lube oil connection 352-0099B
Lubricating oil pipes in flywheel end 352-0129C
LT-water pipes in flywheel end 354-0014F
Leak oil pipe, dirty, free end 358-0009D
Leak oil pipe, clean, free end 358-0052B
Leak fuel pipes 358-0108A
Lubricating oil filter 471-0012C
Lube oil module 474-0023C
Low pressure handpump 890-0032A
Description Section
Multi cover B-bank 107-0276B

Multicover A-bank 107-0532A
Multiduct 200-0061A
Main starting valve 217-0005A
Maintenance kit for solenoid valve 452-0101A
Maintenance kit for solenoid valve 452-0102A
Main bearing temperature sensors 507-0036H
Miscellaneous tools 890-0025E
Description Section
Oil strainer for suction pump 100-013A

Oil dipstick 184-0009A
Overspeed trip device 228-0015E
Page 5 / 8
Overspeed trip device 228-0016B

Overspeed trip device 228-001C
Oil nozzle for intermediate gears 352-0013D
Oil pipe 352-0079B
Oil suction pipe 352-0087K
Oil sample valve 474-0007B
Oil level transducer 508-0018A
Description Section
Pump cover 107-0190E

Piston 113-001A
Pulsation damper 156-0243A
Prelubricating oil pump 182-0006B
Prelubricating oil pump 182-0008B
Pressure valve 350-0015B
Pressure pipe from prelube pump 352-0086C
Pressure gauge valve 507-0206B
Pressure gauge valve 507-0485A
Pressure gauge 514-0008B
Description Section
Rocker arms and bearing bracket 143-003A

Running-in filter 471-008A
Description Section
Side covers, lower part 20V32 107-0161B

Side cover, lower part 107-0332B
Side cover 107-0388A
Starting valve 123-0005A
Page 6 / 8
Speed pickup for TC 156-019B

Starting air distributor 211-0008A
Shut-down mechanism assembly 213-0008E
Starting air pipe 357-0022C
Starting air system 357-0189D
Sensors for lube oil 506-0186C
Sensors for control air 506-0213A
Sensor for crankcase pressure 506-0215B
Sensors for multicover, B-bank 506-0241A
Sensors 506-0247A
Sensors for Multicover, A-bank 506-0348C
Sensors on pump cover 506-0349A
Speed sensors 507-0181A
Side cover lower part, A-side 507-0269B
Side cover lower part, B-side 507-0270B
Speed measuring system 507-0277A
Description Section
Turbocharger 156-0018H
Thermostatic element assembly 183-0007A
Turning device, pipes 357-0069A
Turning device 483-0014A
Temperature sensor for exhaust gas 504-0026B
Temperature sensor for exhaust gas 504-0104A
Terminal box 507-0116C
Terminal box 507-0116D
Temperature measuring system for big end bearing 507-0318F
Temperature measuring system for big end bearing 507-0360A
Tools for cylinder liner 810-0001C
Tools for main bearings 810-0002B
Tools for piston 811-0001B
Tools for connecting rod 811-0002B
Tools for cylinder head 812-0001B
Tools for intermediate gear 813-0001B
Page 7 / 8
Tools for injection equipment 816-0004D

Tools for turbocharger 837-0001E
Description Section
Vibration damper 110-0004F

Valve tappet with guide block 145-0001H
Vibration measurements points 156-0056B
Ventilation valve 378-0013B
Description Section
Wet sump 100-0054A

Water connections for pump cover 107-0184A
Water pump 191-0007F
Wiring harness for turbocharger 506-0239A
Wiring harness assembly for lube oil module 507-0514A
Wiring harness for lube oil module 507-0515A
Wiring harness assembly for connecting box 516-0221A
Page 8 / 8
1. Wärtsilä spare parts

By ordering spare parts from Wärtsilä, you receive latest-technology parts that have
undergone extensive laboratory and field tests. Also, you can be sure that the parts you
purchase comply with the classification your Wärtsilä product has to fulfil.
This document gives you instructions on how to order spare parts so that you receive
the right parts fast and accurately.
The possible updates of this spare parts catalogue will be available in English at
Wärtsilä Online Services. If not already connected to Online Services, see
www.wartsila.com/services/support/onlineservices.
Wärtsilä Online Services also provide service bulletins and manual valid for your Wärtsilä
equipment, and allow you to subscribe to e-mail notifications of the updates.
1-1
This page has intentionally been left blank.
1-2
2. Ordering spare parts
2.1 Where to order

Spare parts can be ordered 24/7 through our global service network or via Online
Services. For more information, contact us or go to www.wartsila.com
2.2 Information needed in the order

When ordering spare parts, include the following information in the order:
Ⴠ Product type
Ⴠ Product number(s)
Ⴠ Spare part number
Ⴠ Spare part description
Ⴠ Spare part details (for example size or length)
Ⴠ Quantity of parts
Ⴠ Consignee
Ⴠ Method of forwarding
Ⴠ Purchaser
Spare parts are identified by the product type, product serial number and spare
part number together, so make sure you give this information correctly in the order. You
can find the spare part number, description and details in the spare parts catalogue
sections.
2.2.1 Use the right spare parts catalogue

The spare parts catalogue (SPC) is unique for each product or product series you have
purchased from Wärtsilä. You can find the serial numbers of the products that the SPC is
valid for on the front page of the SPC.
Product type -
Product number PAAE123456
Project -
Fig 2-1 Product number
To receive spare parts that are suitable for your product, make sure that you use the
correct SPC and product number when ordering spare parts.
2-1
2.2.2 Find the right spare part information

Spare part catalogue sections
One spare parts catalogue (SPC) can be valid for a series of products. In that case,
some sections in the SPC can be valid only for some of the products.
If there are multiple serial numbers on the SPC's front page, check from the table of
contents which sections are valid for the product you are ordering spare parts for. In the
table of contents, sections that are product-specific are marked with the product serial
number in the ”Valid for Products” column. If there are no serial numbers in that column,
the section is valid for all the product serial numbers mentioned on the cover page of the
spare part catalogue.
180 Lubricating oil pumps, thermostatic valves
Section Description Valid for Products
181-0006C Lubricating oil pump PAAE000001
181-0008A Lubricating oil pump PAAE000002
182-0008E Prelubricating oil pump
182-0011A Electric motor for prelubricating oil
182-0012E pump Prelubricating pump assembly
182-0014A Turning tool for prelubricating pump
183-0009B Thermostatic valve for lubricating oil
Fig 2-2 Table of contents GUID-53E81CC8-0635-4D64-8D66-346D2E88C38B v2
Spare part information in the sections

The sections contain illustrations, tables and spare parts lists with small illustrations of
the parts and unit or assembly locations.
The spare parts list contains spare part numbers (Part No), part descriptions (Description)
and quantity (Qty). The quantity does not indicate the total number used in your product
but the number found in the displayed unit or assembly.
Spare part numbers can be arranged in layers. This means that you can have a
complete spare part number that includes other parts that are available separately.
2-2
WÄRTSILÄ 32 Spare Parts List 167-0022

Edition: A
Page: 1(4)
Updated: 28.10.2011
Injection valve
167 011
167 047
167 046
167 048
167 005
167 020
Qty Wt. Qty Wt.

Part No. Description [Pcs] [Kg] Part No. Description [Pcs] [Kg]
167 005 Injection valve 1 -
167 020 Nozzle 1 0.5
167 046 Nozzle holder 1 7.0
167 011 O-ring 1 -
167 047 O-ring 1 -
167 048 O-ring 1 -
Qty Wt.
Part No. Description [Pcs] [Kg] Part No.
167 020 Nozzle 1 0.5
167 046 Nozzle holder 1 7.0
167 011 O-ring 1 -
167 047 O-ring 1 -
167 048 O-ring 1 -
Fig 2-3 Spare part numbers GUID-B0B1F2CB-BC2C-4DB4-9B76-424112EA47DC v5
As shown in the figure, the spare part number 167 005 is for the complete injection valve
inside the red rectangle. When ordering the complete injection valve 167 005, the spare
parts 167 046 and 167 020 are included but you can also order them separately.
The parts numbers 167 011, 167 047 and 167 048 outside the red rectangle are not
included when ordering the complete injection valve 167 005 or the spare parts 167 046
and 167 020.
NOTE
If the spare part section contains a note with additional information such as the
length or size of the part, include this information in the order.
2-3
2-4
3. Spare parts identification

Wärtsilä marks the spare parts they deliver with details that help you identify which part
goes to which product. This is useful especially if you have several Wärtsilä products of
the same type but belonging to different series, design or generation and when you keep
stock of the spare parts.
The spare parts identification information includes:
Ⴠ Spare part name (Description)
Ⴠ Spare part number (Code no.)
Ⴠ Extended part number (EPN)
Ⴠ Order number (Order no.)
Ⴠ Product serial numbers (Engine type/no.)
Ⴠ Quantity of the parts ordered (Quantity)
DESCRIPTION LINE
ORIGINAL PARTS
SPARE PART NAME

CODE NO. PART NO. XX
SPARE PART NO. XXX
ORDER NO. ORIGIN QUANTITY
XXX COUNTRY X
ENGINE TYPE/NO. X
XXX/YYY
01036574 0006756971
Fig 3-1 Spare parts slip GUID-18994615-0E87-4431-A04E-6D52503F641A v3
Product number
The product numbers show which Wärtsilä products the part is compatible with.
Spare part number

The spare part number identifies the type of the part and its location in the system.
Extended part number

The extended part numbers help you differentiate parts from each other if you have multiple
Wärtsilä products that have similar parts with the same spare part code but are different in
design or generation. This also includes situations where you have made modifications to
Wärtsilä products that were originally identical.
3-1
3-2
Wärtsilä 32 Spare Parts List 100-0007
Edition: F
Page: 1(2)
Updated: 14.04.2014
Hydraulic jack for main bearing cap
100 131 100 129
387 004
100 128 100 138
387 004
100 082
100 130
100 128
100 127
100 129
387 004
100 135
100 126
387 004
100 131
Qty Wt.
Part No. Description [Pcs] [Kg]
100 082 Hydraulic jack for main 1 15.4

bearing cap
100 126 O-ring (1) 1 -
100 127 O-ring (1) 1 -
100 128 O-ring (1) 2 -
100 129 O-ring (1) 2 -
100 130 O-ring (1) 1 -
100 135 Nut 2 -
100 138 Quick coupling 2 -
100 131 O-ring (1) 2 -
387 004 Glue compound 1 -
NOTE! (1) Only available in set. See page 2.
DBAE577326-
100-0007 Spare Parts List Wärtsilä 32
Edition: F
Page: 2(2)
Updated: 14.04.2014
Hydraulic jack for main bearing cap
100 127
100 126
100 130
100 129
100 142
100 128
100 131
Qty Wt.
100 142 Sealing set 1 -

100 126 O-ring (1) 1 -
100 127 O-ring (1) 1 -
100 128 O-ring (1) 2 -
100 129 O-ring (1) 2 -
100 130 O-ring (1) 1 -
100 131 O-ring (1) 2 -
NOTE! (1) Not available separately.
DBAE577326-
Edition: A
Page: 1(1)
Updated: 18.05.1998
Oil strainer for suction pump
100 093 100 089 100 092
Qty Wt.
100 089 Nut 2 -

100 092 Plate 1 -
100 093 Clamp 1 -
DBAE577326-
Spare Parts List Wärtsilä 32
This page is intentionally left blank.
DBAE577326-
Edition: E
Page: 1(2)
Updated: 04.02.2014
Cylinder liner with anti-polishing ring
100 003
A
100 110
100 023
100 115
100 113
A (1)
Qty Wt.
100 003 Anti-polishing ring 1 3.8

100 023 O-ring 2 -
100 110 Cylinder liner 1 160
100 113 O-ring 1 -
100 115 Water jacket 1 11.9
NOTE! (1) See section 100-
DBAE577326-
Edition: E
Page: 2(2)
Updated: 04.02.2014
Cylinder liner with anti-polishing ring
387 038
Qty Wt.
387 038 Contact lubrication 1 -
DBAE577326-
Edition: C
Page: 1(2)
Updated: 15.04.2009
Grounding equipment
V-Engine
100 249
100 247
A 100 248
Alternative location
100 247
100 248
Qty Wt.
100 247 Screw 4 -

100 248 Washer 4 -
100 249 Cable set 1 0.7
DBAE577326-
Edition: C
Page: 2(2)
Updated: 15.04.2009
Grounding equipment
L-Engine
100 247
100 248
100 249
Alternative location
100 247
100 248
Qty Wt.
100 247 Screw 4 -

100 248 Washer 4 -
100 249 Cable set 1 0.7
DBAE577326-
Edition: A
Page: 1(2)
Updated: 29.06.2010
Wet sump
100 087
100 085 100 040 100 040

100 131
471 299
100 035 471 123

100 086
A B
See 100-
100 085
100 040
Qty Wt.
100 035 Oil sump 1 2860

100 040 Screw 34 -
100 085 Pipe union 2 -
100 086 Pipe 1 -
100 087 Washer 52 -
100 131 O-ring 36 -
471 123 Screw 24 -
471 299 Screw 24 -
DBAE577326-
Edition: A
Page: 2(2)
Updated: 29.06.2010
Wet sump
100 039 100 039

View A View B
100 044 100 047
100 045 100 083 100 082
100 064
100 084 100 084
C D 100 090
C D
100 036 100 087 100 067

100 203 100 059
100 088 100 202
387 006 100 060 100 038
100 051 100 310
100 217 Section C - C Section D - D

100 068 100 084 100 084
100 087 100 039 100 039
100 131 100 309 100 311 100 047

100 306 100 083
Qty Wt. Qty Wt.
100 036 Flange 1 - 100 306 O-ring 1 -

100 038 O-ring 1 - 100 309 Nut 24 -
100 039 Screw 16 - 100 310 Screw 4 -
100 044 Flange 1 7.4 100 311 Flange 1 1.9
100 045 O-ring 1 - 387 006 Glue compound 1 -
100 047 Flange 2 2.4
100 051 Screw 12 0.3
100 059 Plug 1 -
100 060 Gasket 1 -
100 064 O-ring 1 -
100 067 Screw 68 -
100 068 Screw 24 -
100 082 Hydraulic jack for main 1 15.4
bearing cap
100 083 Gasket 2 -
100 084 Washer 16 -
100 087 Washer 52 -
100 088 Flange 1 1.4
100 090 Rubber band 1 -
100 131 O-ring 36 -
100 202 Washer 68 -
100 217 Washer 12 -
DBAE577326-
Edition: A
Page: 1(5)
Updated: 17.04.2012
Engine block
100 222
100 223
X
100 103 100 222 (1)
100 028 100 223 (1)
100 007 100 001
100 185
100 102
100 186
100 100 100 102
100 327
100 008
387 002
100 187 100 238
100 107 100 184
387 018 100 239
Qty Wt.
100 001 Engine block 1 -

100 007 Main bearing shell, * -
upper
100 008 Main bearing shell, * -
lower
100 028 Thrust bearing 4 -
100 100 Pin 4 -
100 102 Screw * -
100 103 Screw 6 -
100 107 Main bearing cap 1 -
100 184 Main bearing cap * -
100 185 Screw 8 -
100 186 Guiding washer 4 -
100 187 Sealing push-in cap * -
100 222 Plug * -
100 223 Sealing ring * -
100 238 Blind flange * -
100 239 Screw * -
100 327 Distance sleeve * -
NOTE! (1) Not used in all installations.

NOTE! * See page 5.
DBAE577326-
Edition: A
Page: 2(5)
Updated: 17.04.2012
Engine block
100 166
387 018
100 104
100 188
100 189
100 187 100 284

100 286
Qty Wt.
100 104 Screw * -

100 188 Screw 4 -
100 189 Screw 4 -
100 284 Screw 4 -
100 286 Flange 1 -
NOTE! * See page 5.
DBAE577326-
Edition: A
Page: 3(5)
Updated: 17.04.2012
Engine block
100 157
100 165
100 175
A
B
A
B
100 015
100 027
100 097
100 013 100 017 100 010
Qty Wt.
100 010 Round nut * -

100 013 Side screw, long * -
100 015 O-ring * -
100 017 Main bearing screw * -
100 027 Cap * -
100 097 Round nut * -
100 157 Screw 4 -
100 165 Blind flange 1 -
100 175 O-ring 1 -
NOTE! * See page 5.
DBAE577326-
Edition: A
Page: 4(5)
Updated: 17.04.2012
Engine block
Section A-A View X

100 010
100 194 100 024
100 025
Section B-B
100 194
100 005
Qty Wt.
100 005 Camshaft bearing bush * -

100 010 Round nut * -
100 024 Cylinder head screw * -
100 025 O-ring * -
100 194 Bearing bush 8 -
NOTE! * See page 5.
DBAE577326-
Edition: A
Page: 5(5)
Updated: 17.04.2012
Engine block
Quantity according to number of cylinders
Part No. and Description Quantity in pieces

12V 16V 18V 20V
100 005 Camshaft bearing bush 12 16 18 20
100 007 Main bearing shell, upper 8 10 11 12
100 008 Main bearing shell, lower 8 10 11 12
100 010 Round nut 64 84 94 104
100 013 Side screw, long 16 20 22 24
100 015 O-ring 16 20 22 24
100 017 Main bearing screw 16 20 22 24
100 024 Cylinder head screw 48 64 72 80
100 025 O-ring 48 64 72 80
100 027 Cap 16 20 22 24
100 097 Round nut 16 20 22 24
100 102 Screw 76 100 112 124
100 104 Screw 33 45 51 57
100 166 Sealing push-in cap 14 18 20 22
100 184 Main bearing cap 7 9 10 11
100 187 Sealing push-in cap 16 20 22 24
100 222 Plug 2 2 1 1
100 223 Sealing ring 2 2 1 1
100 238 Blind flange 14 18 20 22
100 239 Screw 28 36 40 44
100 327 Distance sleeve 24 32 36 40
DBAE577326-
DBAE577326-
Edition: F
Page: 1(2)
Updated: 05.02.2009
Crankcase cover with relief valve
107 014
107 016
107 015
107 538 107 112 107 013
107 664
107 009
Qty Wt.
107 013 Crankcase cover with 1 -

relief valve
107 009 O-ring 1 -
107 014 Crankcase cover 1 -
107 015 Screw 6 -
107 016 Relief valve 1 -
107 112 Washer 12 -
107 538 Nut 6 -
107 664 Gasket 1 -
DBAE577326-
Edition: F
Page: 2(2)
Updated: 05.02.2009
Crankcase cover with relief valve
107 014
107 538
107 016
107 015
107 112
107 009 107 664
Qty Wt.
107 009 O-ring 1 -

107 015 Screw 6 -
107 016 Relief valve 1 -
107 112 Washer 12 -
107 538 Nut 6 -
107 664 Gasket 1 -
DBAE577326-
Edition: H
Page: 1(3)
Updated: 17.03.2008
Casing, covers, end plates V32
107 018 107 028

A-bank
107 025 107 043
107 035
107 018
107 027
107 114
107 030
107 518
107 010 107 018

107 018 107 026
107 030 107 030
107 041 107 041
107 113 107 115
107 274 107 274
Qty Wt.
107 010 Crankcase cover * -

107 018 Nut * -
107 025 Cover for camshaft * -
107 027 Cover for camshaft gear 2 -
107 028 Cover 1 -
107 030 Washer * -
107 035 Hose gasket * -
107 041 Screw * -
107 043 Screw 4 -
107 114 Hose gasket 2 -
107 274 O-ring * -
107 518 Screw 2 -
NOTE! * See page 3.
DBAE577326-
Edition: H
Page: 2(3)
Updated: 17.03.2008
B-bank
107 043
107 018
107 273
107 027 107 018
107 114 107 025
107 030 107 035
107 518
107 013
107 018
107 026
107 030
A
107 041
107 115
107 018
107 274
107 041 107 030
Section A-A
107 030 107 041
107 274
107 274
Qty Wt.
107 013 Crankcase cover with * -

relief valve (1)
107 018 Nut * -
107 025 Cover for camshaft * -
107 027 Cover for camshaft gear 2 -
107 030 Washer * -
107 041 Screw * -
107 043 Screw 4 -
107 273 Cover 1 -
107 274 O-ring * -
107 518 Screw 2 -
NOTE! (1) See 107-.

NOTE! * See page 3.
DBAE577326-
Edition: H
Page: 3(3)
Updated: 17.03.2008

12V 16V 18V 20V
107 010 Crankcase cover 6 8 9 10
107 013 Crankcase cover with relief valve 6 8 9 10
107 018 Nut 82 106 118 130
107 025 Cover for camshaft 12 16 18 20
107 030 Washer 30 40 42 46
107 035 Hose gasket 12 16 18 20
107 041 Screw 28 38 40 44
107 113 Hose gasket 6 8 9 10
107 274 O-ring 28 38 40 44
DBAE577326-
DBAE577326-
Edition: C
Page: 1(2)
Updated: 19.07.2007
End cover
107 047
107 704 387 025
107 414
107 045
107 047
107 516
107 416
107 515
107 406 107 403 107 403
107 405 107 401 107 406 107 405
Qty Wt.
107 045 Screw 5 -

107 047 Screw 28 -
107 401 End cover 1 120
107 403 Plug 2 -
107 405 Sealing ring 2 -
107 406 Screw 2 0.1
107 414 O-ring 1 0.1
107 416 O-ring 1 -
107 515 Flange 1 5.8
107 516 O-ring 1 -
107 704 End cover, complete 1 30.2
DBAE577326-
Edition: C
Page: 2(2)
Updated: 19.07.2007
End cover
107 704
107 180
107 045 107 044
387 031
107 179
Qty Wt.
107 704 End cover, complete 1 30.2

107 044 Pin 4 -
107 045 Screw 4 -
107 179 End cover 1 15.0
107 180 End cover 1 15.0
DBAE577326-
Edition: A
Page: 1(1)
Updated: 15.07.2003
Cover for Hot-box end piece
107 550
107 551
Qty Wt.
107 550 Cover plate 1 -

107 551 Screw 4 -
DBAE577326-
DBAE577326-
Edition: A
Page: 1(1)
Updated: 15.12.2004
Heat shield for indicator valve
107 602 107 604

A
Section A-A
107 601
107 606
107 603
Qty Wt.
107 606 Heat shield 1 0.3

107 601 Cover 1 0.2
107 602 Cover 1 -
107 603 Support sleeve 1 -
107 604 Pin 1 -
DBAE577326-
DBAE577326-
Edition: A
Page: 1(1)
Updated: 15.12.2004
Heat shield for indicator valve
107 606
See 107-
107 605
107 519
Qty Wt.
107 519 Cover for indicator valve 1 0.8

107 605 Screw 2 -
107 606 Heat shield 1 0.3
DBAE577326-
DBAE577326-
Edition: C
Page: 1(3)
Updated: 24.09.2012
Covers in the free end
107 546
107 546 107 545
107 744 107 542
Qty Wt.
107 542 Support 1 -

107 545 Screw 2 -
107 546 Screw 2 -
107 744 Washer 2 -
DBAE577326-
Edition: C
Page: 2(3)
Updated: 24.09.2012
107 250 107 239

107 244 107 244
107 511 107 511
107 251 107 240
107 245 107 245
107 511 107 511
Qty Wt.
107 239 Cover 1 -

107 240 Cover 1 -
107 244 Nut 4 -
107 245 Screw 4 -
107 250 Cover 1 -
107 251 Cover 1 -
107 511 Washer 8 -
DBAE577326-
Edition: C
Page: 3(3)
Updated: 24.09.2012
View A 107 259

107 267
107 547
107 266
107 548
107 509
107 510
107 544
107 508
A
107 256
Qty Wt.
107 256 Support 1 -

107 259 Cover 1 -
107 266 Screw 4 -
107 267 Screw 4 -
107 508 Screw 13 -
107 509 Cover 1 -
107 510 Cover 1 -
107 544 Screw 6 -
107 547 Screw (1) 2 -
107 548 Screw 4 -
DBAE577326-
DBAE577326-
Edition: B
Page: 1(2)
Updated: 26.03.2012
Side covers, lower part 20V32
A-Bank
107 022 107 133 107 241
Qty Wt.
107 022 Side cover, lower part 1 -

DBAE577326-
Edition: B
Page: 2(2)
Updated: 26.03.2012
Side covers, lower part 20V32
B-Bank
107 241 107 133 107 249
Qty Wt.

DBAE577326-
Edition: A
Page: 1(2)
Updated: 11.03.2008
Equipment for LT-water thermostat valve
View A
107 060
B B
107 339
107 741
A
See 196-
Qty Wt.
107 060 Screw 10 -

107 339 O-ring 2 -
107 741 Pin 2 -
DBAE577326-
Edition: A
Page: 2(2)
Updated: 11.03.2008
Equipment for LT-water thermostat valve
Section B-B
107 339
Qty Wt.
107 339 O-ring 2 -
DBAE577326-
Edition: A
Page: 1(1)
Updated: 25.03.2008
Water connections for pump cover
View A
107 324
107 323
107 326
107 325 107 325
Qty Wt.
107 323 Bend 1 -

107 324 Bend 1 -
107 325 Bend 2 -
107 326 Bend 1 -
DBAE577326-
DBAE577326-
Edition: A
Page: 1(2)
Updated: 26.03.2008
Equipment for HT-water thermostat valve
View A
107 060
B B
107 339
See 196-
Qty Wt.
107 060 Screw 10 -

107 339 O-ring 2 -
DBAE577326-
Edition: A
Page: 2(2)
Updated: 26.03.2008
Equipment for HT-water thermostat valve
Section B-B
107 339
Qty Wt.
107 339 O-ring 2 -
DBAE577326-
Edition: C
Page: 1(2)
Updated: 30.07.2008
Equipment for pump cover
107 310
387 025
107 315
107 320
107 303 107 303
107 060
Qty Wt.
107 060 Screw 10 -

107 303 Screw 3 -
107 310 Screw 19 -
107 315 Plug 2 -
DBAE577326-
Edition: C
Page: 2(2)
Updated: 30.07.2008
107 318
107 318
107 322
107 438
107 312
107 335
107 748
Qty Wt.
107 312 Screw 4 -

107 318 Cylindrical pin 2 -
107 322 Bend 1 -
107 335 O-ring 1 -
107 438 O-ring 2 -
107 748 O-ring 1 -
DBAE577326-
Edition: B
Page: 1(3)
Updated: 28.05.2008
107 315 A
107 320
107 306
107 344
107 330
Qty Wt.
107 306 Screw 5 -

107 315 Plug 2 -
107 330 O-ring 1 -
107 344 Screw 4 -
DBAE577326-
Edition: B
Page: 2(3)
Updated: 28.05.2008
107 307 107 067 View A 107 333 107 067

107 329 107 096 107 096
107 332 473 116 107 333 473 116 *
107 431 107 308

B 107 307
107 329
107 332
C 107 431
B C
Qty Wt.
107 067 Flange 2 -

107 096 O-ring 2 -
107 307 Screw 10 -
107 308 Screw 3 -
107 329 Flange 3 -
107 332 O-ring 3 -
107 333 O-ring 2 -
107 431 O-ring 3 -
473 116 O-ring 2 -
NOTE! *) Position if cooling system with

CAC 1-stage separated
DBAE577326-
Edition: B
Page: 3(3)
Updated: 28.05.2008
Section B-B Section C-C
107 336
107 336
Qty Wt.
107 336 O-ring 3 -
DBAE577326-
DBAE577326-
Edition: E
Page: 1(4)
Updated: 02.07.2010
Pump cover
107 328 387 025 A CWR 107 315
387 017 107 320 107 309
191 002 107 327
See 191- 107 655
107 304 107 315

107 802 107 320
107 803
107 535
387 017
107 536
107 337 387 017
107 747
191 001
107 535
See 191-
107 536
387 017 387 025
107 745 107 535 107 316 181 001 107 316 107 315
107 536 107 321 See 181- 107 321 107 320
387 017 387 017 387 017

Qty Wt.
107 304 Screw 8 -

107 309 Screw 12 -
107 315 Plug 8 -
107 316 Plug 3 -
107 328 Flange 1 -
107 337 O-ring 2 -
107 535 Plug 3 -
107 655 O-ring 2 -
107 745 Screw 8 -
107 803 Plug 1 -
181 001 Lubricating oil pump 1 -
191 001 HT water pump 1 -
191 002 LT water pump 1 -
DBAE577326-
Edition: E
Page: 2(4)
Updated: 02.07.2010
Pump cover
107 328 387 025 A CCWR 107 315
387 017 107 320 107 309
191 002 107 327
See 191- 107 655
107 304 107 315
107 802 107 320
107 803 107 535
387 017 107 536

387 017
107 337
107 747 191 001
107 535 See 191-
107 536 387 025

387 017 107 315
107 745 107 535 107 316 181 001 107 316 107 320
107 536 107 321 See 181- 107 321
387 017 387 017 387 017

Qty Wt.
107 304 Screw 8 -

107 309 Screw 12 -
107 315 Plug 8 -
107 316 Plug 3 -
107 328 Flange 1 -
107 337 O-ring 2 -
107 535 Plug 3 -
107 655 O-ring 2 -
107 745 Screw 8 -
107 803 Plug 1 -
DBAE577326-
Edition: E
Page: 3(4)
Updated: 02.07.2010
Pump cover
107 057 107 087
387 017
B B
107 068
107 071
107 088
107 090
107 334
Qty Wt.
107 057 Screw 8 -

107 068 Pipe clamp 1 -
107 071 Screw 2 -
107 087 Oil distributor 1 -
107 088 Pipe 1 -
107 334 O-ring 1 -
DBAE577326-
Edition: E
Page: 4(4)
Updated: 02.07.2010
Pump cover
107 309
107 430
View A Section B-B
107 338
107 319
107 429 107 337 107 064
107 104
107 064
Qty Wt.
107 064 O-ring 1 -

107 104 Nipple 1 -
107 309 Screw 12 -
107 319 O-ring 1 -
107 337 O-ring 2 -
107 338 O-ring 1 -
107 430 Washer 4 -
DBAE577326-
Edition: F
Page: 1(4)
Updated: 09.05.2014
Equipment for water pump
C
107 094
107 310
107 689
107 690
A
107 903
A
387 003
B
107 310
D
107 313
107 746
D
107 779
387 003
Qty Wt.
107 094 Valve * 1 -

107 310 Screw 8 0.1
107 313 Screw 6 0.2
107 689 Stud 6 0.2
107 690 Nut 6 -
107 746 Valve 1 -
107 779 Washer 6 -
107 903 Washer 6 -
NOTE! *) See page 4.
DBAE577326-
Edition: F
Page: 2(4)
Updated: 09.05.2014
A-A B-B
107 689 107 310 107 317
107 690 387 003
107 903
387 003
Qty Wt.
107 310 Screw 8 0.1

107 689 Stud 6 0.2
107 690 Nut 6 -
107 903 Washer 6 -
DBAE577326-
Edition: F
Page: 3(4)
Updated: 09.05.2014
C-C D-D
107 809
387 003
107 746
107 310
107 313 387 003
107 779
387 003
Qty Wt.
107 310 Screw 8 0.1

107 313 Screw 6 0.2
107 746 Valve 1 -
107 779 Washer 6 -
107 809 Screw 6 -
DBAE577326-
Edition: F
Page: 4(4)
Updated: 09.05.2014
107 177
107 094
107 178
107 177
Qty Wt.
107 094 Valve 1 -

107 177 O-ring 2 -
107 178 O-ring 1 -
DBAE577326-
Edition: A
Page: 1(2)
Updated: 18.12.2008
Cover plate for cylinderhead cover
107 776
107 884
107 774
Qty Wt.
107 774 O-ring 1 -

107 776 Screw 4 -
DBAE577326-
Edition: A
Page: 2(2)
Updated: 18.12.2008
Cover plate for cylinderhead cover
107 776
107 884
107 774
Qty Wt.
107 774 O-ring 1 -

107 776 Screw 4 -
DBAE577326-
Edition: A
Page: 1(2)
Updated: 01.12.2009
Cover for cylinder head
107 521
A A
107 363
107 145
107 144
387 026
Qty Wt.
107 363 Cover for cyl. head 1 -

107 144 Pin 2 -
107 145 Retaining ring 2 -
107 521 Cover 1 -
DBAE577326-
Edition: A
Page: 2(2)
Updated: 01.12.2009
Section A-A
107 140 107 003

107 141
107 139
107 142
107 138
107 143
107 002
387 005
Qty Wt.

107 003 Screw 2 -
107 138 Cover 1 -
107 139 Spring retainer 2 -
107 140 Sealing washer 2 -
107 141 Spring 2 -
107 142 Washer 2 -
DBAE577326-
Edition: A
Page: 1(2)
Updated: 01.12.2009
107 523
A A
107 505
107 145
107 144
387 026
Qty Wt.

107 144 Pin 2 -
107 523 Cover 1 -
DBAE577326-
Edition: A
Page: 2(2)
Updated: 01.12.2009
Section A-A
107 140 107 003

107 141
107 139
107 142
107 138
107 143
107 002
387 005
Qty Wt.

107 003 Screw 2 -
107 138 Cover 1 -
107 141 Spring 2 -
107 142 Washer 2 -
DBAE577326-
Edition: B
Page: 1(1)
Updated: 28.07.2015
Covers between cylinder heads
107 359
107 362
107 361
107 360 107 236
Qty Wt.
107 236 Cover 1 6.6

107 359 Screw 1 0.1
107 360 Fixing element 1 4.6
107 361 Cover plate 1 1.8
DBAE577326-
DBAE577326-
Edition: B
Page: 1(1)
Updated: 14.06.2013
Covers between cylinder heads
107 359 107 730
107 362 107 731
107 436
107 729 107 365
107 360
Qty Wt.
107 365 Cover 1 9.5

107 359 Screw 1 0.1
107 360 Fixing element 1 4.6
107 436 Cover 1 4.5
107 729 Cover 1 0.2
107 730 Screw 2 -
107 731 Nut 2 -
DBAE577326-
DBAE577326-
Edition: A
Page: 1(2)
Updated: 12.08.2009
107 148 107 150 107 804

107 149
107 145
A A
107 144
387 026
107 001
Qty Wt.

107 144 Pin 2 -
107 148 Plate 1 -
107 149 Screw 6 -
107 150 Cover 1 -
107 804 Screw 1 -
DBAE577326-
Edition: A
Page: 2(2)
Updated: 12.08.2009
Section A-A
107 140
107 139
107 141
107 142
107 003
107 138
107 143
107 002
387 005
Qty Wt.

107 003 Screw 2 -
107 138 Cover 1 -
107 141 Spring 2 -
107 142 Washer 2 -
DBAE577326-
Edition: A
Page: 1(2)
Updated: 09.12.2009
107 137
107 145
A A
107 144
387 026
107 116
Qty Wt.

107 137 Cover 1 -
107 144 Pin 2 -
DBAE577326-
Edition: A
Page: 2(2)
Updated: 09.12.2009
Section A-A
107 140
107 139
107 141
107 142
107 003
107 138
107 143
107 002
387 005
Qty Wt.

107 003 Screw 2 -
107 138 Cover 1 -
107 141 Spring 2 -
107 142 Washer 2 -
DBAE577326-
Edition: A
Page: 1(2)
Updated: 09.12.2009
107 151
107 145
A A
107 144
387 026
107 117
107 146 107 805

107 147
Qty Wt.

107 144 Pin 2 -
107 146 Plate 1 -
107 147 Screw 6 -
107 151 Cover 1 -
107 805 Screw 1 -
DBAE577326-
Edition: A
Page: 2(2)
Updated: 09.12.2009
Section A-A
107 140
107 139
107 141
107 142
107 003
107 138
107 143
107 002
387 005
Qty Wt.

107 003 Screw 2 -
107 138 Cover 1 -
107 141 Spring 2 -
107 142 Washer 2 -
DBAE577326-
Edition: B
Page: 1(2)
Updated: 05.02.2016
Multi cover B-bank
107 439 A 107 385
107 385 107 439

107 384 107 386
107 383 107 387
107 373
A
107 390 107 447
387 025
107 377
107 391
107 440 107 370
107 389
107 368
107 374
107 387
107 375
107 376 107 388
Qty Wt.
107 391 Cover 1 -

107 368 End cover 1 167
107 370 Screw 8 -
107 373 Screw 1 -
107 374 O-ring 2 -
107 375 Flange 2 0.9
107 376 Screw 8 -
107 377 Plug 3 -
107 383 Cover 1 0.4
107 384 Screw 3 -
107 385 Plug 3 -
107 386 Screw 1 -
107 387 Pin 2 -
107 388 Screw 7 0.1
107 389 Pipe union 1 0.3
107 390 Screw 6 -
107 447 Flange 1 3.0
DBAE577326-
Edition: B
Page: 2(2)
Updated: 05.02.2016
Multi cover B-bank
A-A
350 134
387 056
Qty Wt.
350 134 O-ring 2 -

DBAE577326-
Edition: B
Page: 1(2)
Updated: 15.11.2011
Covers in the flywheel end
107 720 107 789

107 789 107 791
107 893
107 787
107 549
107 654
107 263
107 652
Qty Wt.
107 263 Screw 30 -

107 549 Screw 9 -
107 652 Cover 1 -
107 654 Cover 1 -
107 720 Screw 1 -
107 787 Plate 1 -
107 789 Washer 7 -
107 791 Nut 2 -
107 893 Screw 2 -
DBAE577326-
Edition: B
Page: 2(2)
Updated: 15.11.2011
Covers in the flywheel end
107 268 107 762 107 734

107 263 107 549 107 789
107 269 107 854
107 789
107 853 107 852
107 855 107 854
107 719 107 700
107 721 107 701
107 721 107 790
107 920
107 792
107 272
107 701
107 790
107 616
Qty Wt.
107 263 Screw 30 -

107 268 Cover 1 -
107 269 Cover 1 -
107 272 Support 1 -
107 549 Screw 9 -
107 616 Plate 1 -
107 700 Support 1 -
107 701 Screw 4 -
107 719 Bracket 2 -
107 721 Screw 5 -
107 734 Bracket 1 -
107 762 Cover 1 -
107 789 Washer 7 -
107 790 Washer 4 -
107 792 Screw 4 -
107 852 Bracket 1 -
107 853 Screw 3 -
107 854 Screw 4 -
107 855 Washer 3 -
107 920 Bracket 1 -
DBAE577326-
Edition: B
Page: 1(1)
Updated: 04.03.2015
Side cover, lower part
107 022
107 133
107 241
107 158
107 249
387 042
107 164
107 162
107 163
Qty Wt.
107 022 Side cover, lower part 1 9.0

107 158 Hose gasket (1) 1 -
107 162 Screw 4 -
107 163 Washer 4 -
107 164 Pressure plate 2 -
107 158 Hose gasket (2) 1 -
107 162 Screw 4 -
107 163 Washer 4 -
107 158 Hose gasket (3) 1 -
107 162 Screw 4 -
107 163 Washer 4 -
107 158 Hose gasket (4) 1 -
107 162 Screw 4 -
107 163 Washer 4 -
NOTE! (1) L= 1376 mm

NOTE! (2) L= 1118 mm
NOTE! (3) L= 1140 mm
NOTE! (4) L= 1376 mm
DBAE577326-
DBAE577326-
Edition: A
Page: 1(2)
Updated: 22.03.2012
Covers
A-bank
107 116 107 505 107 365 107 363 107 116 107 505 107 363 107 116 107 117
107 236
107 001
107 121
107 243
107 021 107 132 107 242
Qty Wt.

107 021 Side cover, upper part 1 -
107 121 Screw 60 -
107 236 Cover 14 -
107 243 Screw 72 -
107 365 Cover 4 -
DBAE577326-
Edition: A
Page: 2(2)
Updated: 22.03.2012
Covers
B-bank
107 001 107 236 107 116 107 505 107 365 107 363 107 116 107 505 107 363 107 116
107 117
107 121
107 243
107 252 107 132 107 247
Qty Wt.

107 121 Screw 60 -
107 236 Cover 14 -
107 243 Screw 72 -
107 365 Cover 4 -
DBAE577326-
Edition: A
Page: 1(4)
Updated: 08.08.2013
Side cover
X
107 166
107 173
387 003 A
107 486 107 165
107 162 107 021
107 163
107 164
107 162
107 163
107 158
387 005
Qty Wt.
107 021 Side cover, upper part * 1 -

107 158 Hose gasket (1) 1 -
107 162 Screw 6 -
107 163 Washer 6 -
107 165 Support (2) 1 0.1
107 166 Screw 2 -
107 173 Support 1 -
NOTE! (1) L= 1371 mm

NOTE! (2) See page 4.
NOTE! *) See 107-
DBAE577326-
Edition: A
Page: 2(4)
Updated: 08.08.2013
Side cover
107 153 107 154
107 160
107 487
107 489
107 160
107 491
107 487
387 003
107 490
107 491
107 167
Qty Wt.
107 153 Bracket 1 1.3

107 154 Bracket 1 1.1
107 160 Screw 8 -
107 167 Cover 1 15.6
107 489 End plate 1 0.3
107 490 End plate 1 0.3
107 491 Screw 24 -
107 487 Washer 10 -
DBAE577326-
Edition: A
Page: 3(4)
Updated: 08.08.2013
Side cover
107 485 107 483

107 484 107 488 107 157
107 487
107 487
107 923
107 160
387 003
107 157
107 481
Qty Wt.
107 157 Screw 6 -

107 160 Screw 8 -
107 481 Rubber element 2 -
107 483 Hinge 2 0.2
107 484 Hinge 2 0.3
107 485 Hinge shaft 2 -
107 487 Washer 10 -
107 923 Side cover, upper part 1 8.0
DBAE577326-
Edition: A
Page: 4(4)
Updated: 08.08.2013
Side cover
107 495
107 494
107 493
107 165
107 492
Qty Wt.
107 165 Support 1 0.1

107 492 Round bar 1 -
107 493 Nut 1 -
107 494 Joint yoke 1 -
107 495 Securing pin 1 -
DBAE577326-
Edition: A
Page: 1(4)
Updated: 08.08.2013
Side cover
X
107 166
107 173
387 003 A
107 486 107 165
107 162 107 132
107 163
107 164
107 162
107 163
107 158
387 005
Qty Wt.

107 158 Hose gasket (1) 1 -
107 162 Screw 6 -
107 163 Washer 6 -
107 165 Support (2) 1 0.1
107 166 Screw 2 -
107 173 Support 1 -
NOTE! (1) L=1111mm

NOTE! *) See 107-
DBAE577326-
Edition: A
Page: 2(4)
Updated: 08.08.2013
Side cover
107 153 107 154
107 160
107 487
107 489
107 160
107 491
107 487
387 003
107 490
107 491
107 278
Qty Wt.

107 489 End plate 1 0.3
107 490 End plate 1 0.3
107 491 Screw 24 -
107 153 Bracket 1 1.3
107 154 Bracket 1 1.1
107 160 Screw 8 -
107 487 Washer 10 -
DBAE577326-
Edition: A
Page: 3(4)
Updated: 08.08.2013
Side cover
107 485 107 483

107 484 107 488 107 157
107 487
107 487
107 279
107 160
387 003
107 157
107 481
Qty Wt.
107 157 Screw 6 -

107 160 Screw 8 -
107 483 Hinge 2 0.2
107 484 Hinge 2 0.3
107 487 Washer 10 -
DBAE577326-
Edition: A
Page: 4(4)
Updated: 08.08.2013
Side cover
107 495
107 494
107 493
107 165
107 492
Qty Wt.
107 165 Support 1 0.1

107 492 Round bar 1 -
107 493 Nut 1 -
DBAE577326-
Edition: A
Page: 1(4)
Updated: 09.08.2013
Side cover
X
107 166
107 173
387 003 A
107 486 107 165
107 162 107 242
107 163
107 164
107 162
107 163
107 158
387 005
Qty Wt.

107 158 Hose gasket (1) 1 -
107 162 Screw 6 -
107 163 Washer 6 -
107 165 Support (2) 1 0.1
107 166 Screw 2 -
107 173 Support 1 -
NOTE! (1) L=1131mm

NOTE! *) See 107-
DBAE577326-
Edition: A
Page: 2(4)
Updated: 09.08.2013
Side cover
107 153 107 154
107 160
107 487
107 489
107 160
107 491
107 487
387 003
107 490
107 491
107 280
Qty Wt.
107 153 Bracket 1 1.3

107 154 Bracket 1 1.1
107 160 Screw 8 -
107 489 End plate 1 0.3
107 490 End plate 1 0.3
107 491 Screw 24 -
107 487 Washer 10 -
DBAE577326-
Edition: A
Page: 3(4)
Updated: 09.08.2013
Side cover
107 485 107 483

107 484 107 488 107 157
107 487
107 487
107 281
107 160
387 003
107 157
107 481
Qty Wt.
107 157 Screw 6 -

107 160 Screw 8 -
107 483 Hinge 2 0.2
107 484 Hinge 2 0.3
107 487 Washer 10 -
DBAE577326-
Edition: A
Page: 4(4)
Updated: 09.08.2013
Side cover
107 495
107 494
107 493
107 165
107 492
Qty Wt.
107 165 Support 1 0.1

107 492 Round bar 1 -
107 493 Nut 1 -
DBAE577326-
Edition: A
Page: 1(5)
Updated: 09.08.2013
Side cover
107 486 107 165
107 162 107 252
107 163
107 164
107 162
107 163
107 158
387 005
Qty Wt.

107 158 Hose gasket (1) 1 -
107 162 Screw 6 -
107 163 Washer 6 -
107 165 Support (2) 1 0.1
NOTE! (1) L=1601mm

NOTE! *) See 107-
DBAE577326-
Edition: A
Page: 2(5)
Updated: 09.08.2013
Side cover
107 154
107 153 107 482
A B
107 160
107 487
387 003 107 160

A B
107 166 107 487
107 173 387 003
387 003
107 490 107 489
107 491 107 276 107 491
Qty Wt.
107 153 Bracket 1 1.3

107 154 Bracket 1 1.1
107 160 Screw 12 -
107 166 Screw 2 -
107 173 Support 1 -
107 489 End plate 1 0.3
107 490 End plate 1 0.3
107 491 Screw 24 -
107 482 Support 1 1.7
107 487 Washer 15 -
DBAE577326-
Edition: A
Page: 3(5)
Updated: 09.08.2013
Side cover
A-A
107 485 107 483

107 484 107 160
107 487
107 487 387 003
107 277
107 160
387 003
107 157
107 481
Qty Wt.
107 157 Screw 9 -

107 160 Screw 12 -
107 483 Hinge 3 0.2
107 484 Hinge 3 0.3
107 487 Washer 15 -
DBAE577326-
Edition: A
Page: 4(5)
Updated: 09.08.2013
Side cover
B-B
107 488 107 157

107 487
107 487
107 160
387 003
107 157
107 481
Qty Wt.
107 157 Screw 9 -

107 160 Screw 12 -
107 487 Washer 15 -
DBAE577326-
Edition: A
Page: 5(5)
Updated: 09.08.2013
Side cover
107 495
107 494
107 493
107 165
107 492
Qty Wt.
107 165 Support 1 0.1

107 492 Round bar 1 -
107 493 Nut 1 -
DBAE577326-
DBAE577326-
Edition: A
Page: 1(4)
Updated: 09.08.2013
Side cover
X
107 166
107 173
387 003 A
107 486 107 165
107 162 107 247
107 163
107 164
107 162
107 163
107 158
387 005
Qty Wt.

107 158 Hose gasket (1) 1 -
107 162 Screw 6 -
107 163 Washer 6 -
107 165 Support (2) 1 0.1
107 166 Screw 2 -
107 173 Support 1 -
NOTE! (1) L=1369mm

NOTE! *) See 107-
DBAE577326-
Edition: A
Page: 2(4)
Updated: 09.08.2013
Side cover
107 153 107 154
107 160
107 487
107 489
107 160
107 491
107 487
387 003
107 490
107 491
107 282
Qty Wt.
107 153 Bracket 1 1.3

107 154 Bracket 1 1.1
107 160 Screw 8 -
107 489 End plate 1 0.3
107 490 End plate 1 0.3
107 491 Screw 24 -
107 487 Washer 10 -
DBAE577326-
Edition: A
Page: 3(4)
Updated: 09.08.2013
Side cover
107 485 107 483

107 484 107 488 107 157
107 487
107 487
107 283
107 160
387 003
107 157
107 481
Qty Wt.
107 157 Screw 6 -

107 160 Screw 8 -
107 483 Hinge 2 0.2
107 484 Hinge 2 0.3
107 487 Washer 10 -
DBAE577326-
Edition: A
Page: 4(4)
Updated: 09.08.2013
Side cover
107 495
107 494
107 493
107 165
107 492
Qty Wt.
107 165 Support 1 0.1

107 492 Round bar 1 -
107 493 Nut 1 -
DBAE577326-
Edition: A
Page: 1(2)
Updated: 18.12.2013
Covers for air bottle
107 028
107 043
107 027
107 114
107 018
107 518
Qty Wt.
107 018 Nut 8 -

107 027 Cover for camshaft gear 2 9.1
107 028 Cover 1 1.5
107 043 Screw 4 -
107 114 Hose gasket 2 0.2
107 518 Screw 2 -
NOTE! A-bank
DBAE577326-
Edition: A
Page: 2(2)
Updated: 18.12.2013
Covers for air bottle
107 273
107 043
107 027
107 114
107 018
107 518
Qty Wt.
107 018 Nut 8 -

107 027 Cover for camshaft gear 2 9.1
107 043 Screw 4 -
107 114 Hose gasket 2 0.2
107 273 Cover 1 1.5
107 518 Screw 2 -
NOTE! B-bank
DBAE577326-
Edition: A
Page: 1(3)
Updated: 10.02.2016
Multicover A-bank
107 206
107 290
107 354
107 190
107 215 A
107 191
107 189
A
107 512 107 111
B
107 607
107 608
B
107 291
107 227 107 355
107 214 107 291
107 215 107 355
107 183
Qty Wt.
107 111 Cover 1 -

107 183 End cover 1 172
107 189 Screw 1 -
107 190 Cover 1 0.4
107 191 Screw 3 -
107 206 Plug 3 -
107 214 Screw 7 0.1
107 215 Pin 2 -
107 227 Pipe union 1 0.3
107 290 Screw 1 -
107 291 Plug 3 -
107 512 Screw 7 -
107 607 Plug 1 -
DBAE577326-
Edition: A
Page: 2(3)
Updated: 10.02.2016
Multicover A-bank
107 219 107 292 C

107 217
107 218 107 286
107 207
107 284
107 210
C
107 211
107 209
107 208
107 195
B-B
107 612 107 231
387 025
107 196 107 197
107 194
107 220
107 232
107 233
107 193 107 192
107 462 107 613
107 188 107 187

Qty Wt. Qty Wt.
107 187 Distributor (1) 1 17.6 107 462 Pipe 1 0.2

107 188 Screw 6 - 107 612 Screw 8 -
107 192 Pipe 1 0.3 107 613 Flange 1 4.5
107 193 Pipe 1 0.2 387 025 Glue compound 1 -
107 194 Pipe 1 0.2
107 195 Pipe 1 0.3 NOTE! (1) See section 211-
107 196 Pipe 1 0.2
107 197 Pipe 1 0.3
107 207 Bracket 2 -
107 208 Pipe 1 0.2
107 210 Screw 8 -
107 211 Pipe clamp 2 0.2
107 217 Distribution piece 1 11.3
107 218 Screw 6 -
107 219 Screw 2 -
107 220 Pipe union 10 -
107 231 Pipe 1 0.3
107 232 Pipe 1 0.3
107 233 Pipe 1 0.3
107 286 Bracket 2 -
DBAE577326-
Edition: A
Page: 3(3)
Updated: 10.02.2016
Multicover A-bank
350 131
350 133
350 602
387 026
350 134
387 056
107 206
107 354
Qty Wt.
107 206 Plug 3 -

350 131 Locking plate 1 0.1
350 133 Screw 1 -
350 134 O-ring 2 -
350 602 Throttle ring 2 0.6
DBAE577326-
DBAE577326-
Edition: F
Page: 1(2)
Updated: 12.03.2016
Vibration damper
110 067
110 066
110 013
110 074
387 007
Qty Wt.
110 013 Vibration damper 1 421

110 066 O-ring (1) 2 -
110 067 O-ring (1) 2 -
110 074 Spring (1) * -
NOTE! (1) Parts available only as spare part

kit, see next page(s).
NOTE! *) Spring quantity depends on
vibration damper type, (24/30 pcs).
NOTE! Only one kit needed per engine.
DBAE577326-
Edition: F
Page: 2(2)
Updated: 12.03.2016
Vibration damper
110 079
110 066
110 067
110 074
387 007
Qty Wt.
110 079 Spare part kit 1 1.3

110 066 O-ring (1) 2 -
110 067 O-ring (1) 2 -
110 074 Spring (1) * -
NOTE! (1) Parts available only as spare part

kit, see next page(s).
NOTE! *) Spring quantity depends on
vibration damper type, (24/30 pcs).
NOTE! Only one kit needed per engine.
DBAE577326-
Edition: A
Page: 1(3)
Updated: 16.11.2016
Crankshaft
110 005
110 023
110 025 110 022 A
110 077 110 032
110 078 110 033

110 001
110 005 110 026

387 003 110 080 110 002
Qty Wt.
110 001 Crankshaft 1 -

110 002 Counterweight 19 122
110 005 Plug 22 0.5
110 022 Split gear wheel 1 124
110 032 Pin 2 -
110 033 Screw 4 0.4
110 025 Stretcher 8 -
110 026 Screw 14 0.5
110 077 Clamping band *) 2 -
110 078 Clamping screw 1 -
NOTE! *) Length needed when ordering.
DBAE577326-
Edition: A
Page: 2(3)
Updated: 16.11.2016
Crankshaft
A-A
110 004
110 003 110 021
Qty Wt.
110 003 Screw 40 2.7

110 004 Pin 40 -
110 021 Nut 40 0.7
DBAE577326-
Edition: A
Page: 3(3)
Updated: 16.11.2016
Crankshaft
110 027
110 002 110 014

110 002 110 013
Qty Wt.

110 013 Vibration damper (1) 1 -
110 014 Gear wheel 1 61.6
110 027 Screw 18 1.1
NOTE! (1) See installation specific

documentation
DBAE577326-
DBAE577326-
Edition: B
Page: 1(2)
Updated: 08.05.2013
Connecting rod
111 011
111 015 111 006
111 010
111 005
Qty Wt.
111 005 Big end bearing shell, 1 -

lower
111 006 Big end bearing shell, 1 -
upper
111 010 Connecting rod, lower 1 -
part
111 011 Connecting rod, upper 1 -
part
111 015 Shim 1 -
DBAE577326-
Edition: B
Page: 2(2)
Updated: 08.05.2013
Connecting rod
111 002
111 011
111 012
111 003
111 013
111 010
111 013
111 003
111 004
Qty Wt.
111 010 Connecting rod, lower 1 -

part
111 003 Nut 8 -
111 004 Screw 4 -
111 012 Screw 4 -
111 013 Pin 4 -
111 011 Connecting rod, upper 1 -
part
111 002 Gudgeon pin bearing 1 -
bush
DBAE577326-
Edition: A
Page: 1(2)
Updated: 01.10.1996
Piston
113 001 113 002
113 012
113 003
113 004
113 005
113 006
113 013
113 008
113 009
113 010
113 011
Qty Wt.
113 001 Piston 1 82.5

113 002 Pin 1 -
113 003 Piston crown 1 26.6
113 008 Screw 4 0.2
113 011 Piston skirt 1 64.2
113 013 O-ring 1 -
113 012 Piston ring kit 1 -
113 004 Piston ring I 1 -
113 005 Piston ring II 1 -
113 006 Piston ring III 1 -
113 009 Securing ring 2 0.1
113 010 Gudgeon pin 1 33.0
DBAE577326-
Edition: A
Page: 2(2)
Updated: 01.10.1996
Piston
113 001
113 012 113 003
113 004
113 002
113 005
113 006 113 013
113 010
113 011 113 008

113 009
Qty Wt.
113 001 Piston 1 82.5

113 002 Pin 1 -
113 003 Piston crown 1 26.6
113 008 Screw 4 0.2
113 011 Piston skirt 1 64.2
113 013 O-ring 1 -
113 012 Piston ring kit 1 -
113 004 Piston ring I 1 -
113 005 Piston ring II 1 -
113 006 Piston ring III 1 -
113 009 Securing ring 2 0.1
113 010 Gudgeon pin 1 33.0
DBAE577326-
Edition: D
Page: 1(2)
Updated: 19.03.2007
Flywheel
114 001
114 002
114 017
A
114 004
114 005
114 003
View A
Qty Wt.
114 001 Flywheel 1 -

114 002 Fitting screw * -
114 003 Screw 2 -
114 004 Screw * -
114 005 Nut 18 -
114 017 O-ring (1) 1 -
NOTE! (1) Used only with specific type of

flexible coupling.
NOTE! * See page 2
DBAE577326-
Edition: D
Page: 2(2)
Updated: 19.03.2007
Flywheel
18 1 2
17 3
16 4
15 5
14 6
13 7
12 8
11 10 9 * 114 002 * 114 004
Engine type Location of
Number of Number of
fitted bolts
fitted bolts normal screws
12V32 1, 4, 7, 10, 13, 16 6 12
16V32 1, 3, 6, 8, 11, 13, 15, 17 8 10
18V32 1, 3, 5, 7, 9,11,13,15,17 9 9
20V32 1, 3, 5, 7, 9,11,13,15,17,18 10 8
Alternative design
* 114 002 * 114 004
Engine type Location of
Number of Number of
fitted bolts
fitted bolts normal screws
12V32 1, 4, 7, 9, 12, 15, 17 7 11
16V32 1, 3, 5, 7, 9, 11, 13, 15, 17, 18 10 8
18V32 1, 3, 5, 7, 8, 9, 11, 13, 15, 17, 18 11 7
Qty Wt.
NOTE! Alternative design according to

classification society regulations
DBAE577326-
Edition: A
Page: 1(1)
Updated: 19.08.2010
Flywheel
114 035
387 005
114 001
Qty Wt.
114 001 Flywheel 1 -

114 035 Magnet 1 -
DBAE577326-
DBAE577326-
Edition: A
Page: 1(1)
Updated: 01.06.2003
Cylinder head equipment
145 001
145 002
167 012
See 167-
120 012
Qty Wt.
120 012 Gasket 1 0.2

145 001 Push rod 2 5.3
145 002 Protecting pipe 2 1.5
167 012 Injection pipe 1 -
DBAE577326-
DBAE577326-
Edition: C
Page: 1(2)
Updated: 10.10.2011
Cylinder head
121 001 Ex 121 007 In
120 007
120 050
387 036
120 005
120 014
120 013
387 036 120 060
120 050
387 036
120 025
120 053
387 036
120 017 120 022 120 049 120 021
387 036 387 036
Qty Wt.
120 060 Cylinder head with inlet 1 -

and exhaust valve (1)
121 001 Exhaust valve, compl. 2 -
121 007 Inlet valve, compl. 2 -
120 025 Cylinder head (2) 1 -
120 005 Cylinder head 1 -
120 007 Yoke pin 2 -
120 013 Valve guide 4 -
120 014 Sealing push-in cap 6 -
120 017 O-ring 2 -
120 021 Seat ring for inlet 2 -
valve
120 022 Seat ring for outlet 2 -
valve
120 049 Sleeve 1 -
NOTE! (1) With valves

NOTE! (2) Without valves
DBAE577326-
Edition: C
Page: 2(2)
Updated: 10.10.2011
Cylinder head
120 013 120 049 121 001 Ex 121 007 In
387 036
120 007
120 050
387 036
120 050
387 036
120 014
120 053 387 036
387 036
120 005
120 017
120 022 120 021
387 036
Qty Wt.
120 005 Cylinder head 1 -

120 007 Yoke pin 2 -
120 013 Valve guide 4 -
120 017 O-ring 2 -
120 021 Seat ring for inlet valve 2 -
120 022 Seat ring for outlet valve 2 -
120 049 Sleeve 1 -
DBAE577326-
Edition: A
Page: 1(6)
Updated: 28.08.2017
Cylinder head with starting valve
120 002
120 032
121 001
143 001
121 007
167 008
120 003
167 058 167 005

167 060
167 059
120 025 120 001
167 001
123 002
120 084
123 003
123 001 120 031
Qty Wt. Qty Wt.

120 001 Cylinder head 1 - NOTE! (5) See section 121-

120 002 Screw 3 0.7
120 003 O-ring 2 -
120 025 Cylinder head (1) 1 318
120 031 O-ring 1 -
120 032 Washer 3 -
120 084 O-ring 1 -
(5)
121 007 Inlet valve, compl. (5) 2 -
123 001 Starting valve (4) 1 1.2
123 002 Cover 1 1.3
123 003 Screw 4 -
143 001 Rocker arms with 1 33.0
bracket (3)
167 001 O-ring 1 -
167 008 Screw 2 0.2
167 058 Flange 1 0.7
167 059 Flange 1 0.3
167 060 Pair of friction rings 2 -

DBAE577326-
Edition: A
Page: 2(6)
Updated: 28.08.2017
125 011
143 010 143 014 120 033

120 034
120 035
120 123
120 036
120 125
125 010
B A
120 044
120 042
120 028
120 051 145 014
120 052
120 037
120 043
120 025 120 043 120 029 120 038
Qty Wt. Qty Wt.

120 025 Cylinder head (1) 1 318 145 014 Pipe union 1 -
120 028 Pipe 1 -
120 029 Pipe 1 - NOTE! (1) See section 120-
120 033 Screw 2 0.1 NOTE! (3) See section 143-
120 034 Nut 2 - NOTE! (6) See section 125-
120 035 Yoke 1 0.5
120 036 Connection piece 1 0.5
120 037 Screw 2 -
120 042 Screw 2 -
120 044 Gasket 1 -
120 051 Plug 1 -
120 123 Nut 1 -
125 010 Cylinder head safety 1 1.1
valve (6)
125 011 Indicator valve, compl. 1 0.5
(6)
143 010 Yoke for exhaust valve, 1 2.4
compl. (3)
143 014 Yoke for inlet valve, 1 2.4
compl. (3)
DBAE577326-
Edition: A
Page: 3(6)
Updated: 28.08.2017
A B
120 023 120 024
120 121
120 122
Qty Wt.
120 023 Gasket 1 -

120 024 Gasket 1 -
120 121 Plug 2 -
DBAE577326-
Edition: A
Page: 4(6)
Updated: 28.08.2017
120 183
120 184
120 185
120 186
120 187
Qty Wt.
120 183 Screw 4 -

120 184 End flange 1 -
120 185 O-ring 1 -
120 187 Plug 6 -
DBAE577326-
Edition: A
Page: 5(6)
Updated: 28.08.2017
120 003
100 025 145 021
200 056 218 136

120 015
120 012 218 135
120 031 358 023
200 067
120 084
107 143
107 002
200 018
Qty Wt.
120 015 Sealing set for cylinder 1 -

head replacement
100 025 O-ring 4 -
120 003 O-ring 2 -
120 012 Gasket 1 -
120 031 O-ring 1 -
120 084 O-ring 1 -
145 021 O-ring 2 -
200 018 Gasket 1 -
200 056 O-ring 2 -
200 067 Pin 2 -
218 135 O-ring 2 -
218 136 O-ring 2 -
358 023 O-ring 4 -
DBAE577326-
Edition: A
Page: 6(6)
Updated: 28.08.2017
123 010 121 005 120 052 605 032
120 017
120 054 120 044
123 011
167 001 121 011
120 023
120 024
Qty Wt.

head overhaul
120 017 O-ring 2 -
120 023 Gasket 1 -
120 024 Gasket 1 -
120 044 Gasket 1 -
121 005 O-ring 2 -
121 011 O-ring 2 -
123 010 O-ring 1 -
167 001 O-ring 1 -
605 032 O-ring 4 -
DBAE577326-
Edition: A
Page: 1(6)
Updated: 28.08.2017
Cylinder head without starting valve
120 002
120 032
121 001
143 001
121 007
167 008
120 003
167 058 167 005

167 060
167 059
120 025 120 075
167 001
123 002
120 084
123 003
123 020 120 031

123 010 123 011
Qty Wt. Qty Wt.

120 075 Cylinder head 1 - NOTE! (3) See section 143-

120 003 O-ring 2 -
120 025 Cylinder head (1) 1 318
120 031 O-ring 1 -
120 032 Washer 3 -
120 084 O-ring 1 -
(5)
121 007 Inlet valve, compl. (5) 2 -
123 002 Cover 1 1.3
123 003 Screw 4 -
123 010 O-ring 1 -
123 020 Dummy 1 1.8
bracket (3)
167 001 O-ring 1 -
167 008 Screw 2 0.2
167 058 Flange 1 0.7
167 059 Flange 1 0.3
167 005 Injection valve (2) 1 -

DBAE577326-
Edition: A
Page: 2(6)
Updated: 28.08.2017
125 011
143 010 143 014 120 033

120 034
120 035
120 123
120 036
120 125
125 010
B A
120 044
120 042
120 028
120 051 145 014
120 052
120 037
120 043
120 025 120 043 120 029 120 038
Qty Wt. Qty Wt.

120 025 Cylinder head (1) 1 318 145 014 Pipe union 1 -
120 028 Pipe 1 -
120 029 Pipe 1 - NOTE! (1) See section 120-
120 034 Nut 2 - NOTE! (6) See section 125-
120 035 Yoke 1 0.5
120 037 Screw 2 -
120 042 Screw 2 -
120 044 Gasket 1 -
120 051 Plug 1 -
120 123 Nut 1 -
125 010 Cylinder head safety 1 1.0
valve (6)
125 011 Indicator valve, compl. 1 0.5
(6)
143 010 Yoke for exhaust valve, 1 2.4
compl. (3)
143 014 Yoke for inlet valve, 1 2.4
compl. (3)
DBAE577326-
Edition: A
Page: 3(6)
Updated: 28.08.2017
A B
120 023 120 024
120 121
120 122
Qty Wt.
120 023 Gasket 1 -

120 024 Gasket 1 -
120 121 Plug 2 -
DBAE577326-
Edition: A
Page: 4(6)
Updated: 28.08.2017
120 183
120 184
120 185
120 186
120 187
Qty Wt.
120 183 Screw 4 -

120 185 O-ring 1 -
120 187 Plug 6 -
DBAE577326-
Edition: A
Page: 5(6)
Updated: 28.08.2017
120 003
100 025 145 021
200 056 218 136

120 015
120 012 218 135
120 031 358 023
200 067
120 084
107 143
107 002
200 018
Qty Wt.

head replacement
100 025 O-ring 4 -
120 003 O-ring 2 -
120 012 Gasket 1 -
120 031 O-ring 1 -
120 084 O-ring 1 -
145 021 O-ring 2 -
200 018 Gasket 1 -
200 056 O-ring 2 -
200 067 Pin 2 -
218 135 O-ring 2 -
218 136 O-ring 2 -
358 023 O-ring 4 -
DBAE577326-
Edition: A
Page: 6(6)
Updated: 28.08.2017
123 010 121 005 120 052 605 032
120 017
120 054 120 044
123 011
167 001 121 011
120 023
120 024
Qty Wt.

head overhaul
120 017 O-ring 2 -
120 023 Gasket 1 -
120 024 Gasket 1 -
120 044 Gasket 1 -
121 005 O-ring 2 -
121 011 O-ring 2 -
123 010 O-ring 1 -
167 001 O-ring 1 -
605 032 O-ring 4 -
DBAE577326-
Edition: B
Page: 1(2)
Updated: 17.08.2015
Inlet valve with rotocap
121 009 121 008

* 121 021
121 007
121 011
121 010
121 012
Qty Wt.

121 008 Valve cotter pair 1 -
121 009 Rotocap 1 -
121 010 Spring 1 -
121 011 O-ring 1 -
121 012 Inlet valve 1 -
121 021 Rotocap maintenance 1 -
kit
DBAE577326-
Edition: B
Page: 2(2)
Updated: 17.08.2015
Inlet valve with rotocap
121 011 121 008
121 009
121 012
121 018
121 021
121 017 121 015
121 013 121 016
121 014
121 010
Qty Wt.

121 009 Rotocap 1 -
121 010 Spring 1 -
121 011 O-ring 1 -
121 012 Inlet valve 1 -
121 021 Rotocap maintenance kit 1 -
121 013 Spring plate * 1 -
121 014 Retainer ring * 1 -
121 015 Spring * 7 -
121 016 Ball * 7 -
121 017 Ball disc * 1 -
121 018 Spring guide * 7 -
NOTE! *) Can not be ordered separately.
DBAE577326-
Edition: B
Page: 1(2)
Updated: 17.08.2015
Exhaust valve with rotocap
121 003 121 002

* 121 020
121 001
121 005
121 004
121 006
Qty Wt.

121 003 Rotocap 1 -
121 004 Spring 1 -
121 005 O-ring 1 -
121 006 Exhaust valve 1 -
121 020 Rotocap maintenance 1 -
kit
DBAE577326-
Edition: B
Page: 2(2)
Updated: 17.08.2015
Exhaust valve with rotocap
121 005 121 002
121 003
121 006
121 018
121 020
121 017 121 015
121 013 121 016
121 014
121 004
Qty Wt.

121 003 Rotocap 1 -
121 004 Spring 1 -
121 005 O-ring 1 -
121 006 Exhaust valve 1 -
121 020 Rotocap maintenance kit 1 -
121 015 Spring * 7 -
121 016 Ball * 7 -
121 017 Ball disc * 1 -
121 018 Spring guide * 7 -
NOTE! *) Can not be ordered separately.
DBAE577326-
Edition: A
Page: 1(2)
Updated: 28.01.2009
Starting valve
387 029 123 001
123 008 123 007 123 005
123 006 123 010 123 009 123 011
Qty Wt.
123 001 Starting valve 1 2.2

123 005 Spindle 1 0.1
123 006 Piston 1 0.3
123 007 Housing 1 1.7
123 008 Nut 1 -
123 009 Spring 1 -
123 010 O-ring 1 -
387 029 Assembly compound 1 -
DBAE577326-
Edition: A
Page: 2(2)
Updated: 28.01.2009
Starting valve
123 008 123 006 123 009
123 010 123 007 123 011 123 005
Qty Wt.
123 005 Spindle 1 0.1

123 006 Piston 1 0.3
123 007 Housing 1 1.7
123 008 Nut 1 -
123 009 Spring 1 -
123 010 O-ring 1 -
DBAE577326-
Edition: C
Page: 1(1)
Updated: 22.10.2012
Indicator valve
125 011
Qty Wt.
125 011 Indicator valve, compl. 1 -
DBAE577326-
DBAE577326-
Edition: D
Page: 1(3)
Updated: 02.10.2008
Bearing cover for camshaft B-bank
131 078
A B
131 070 131 026
131 071 131 006
131 063
131 073
131 074
Qty Wt.
131 006 O-ring 1 -

131 026 Thrust bearing bush 1 -
131 063 Bearing cover 1 -
131 070 Spring pin 4 -
131 071 O-ring 1 -
131 073 O-ring 1 -
131 074 Plug 1 -
DBAE577326-
Edition: D
Page: 2(3)
Updated: 02.10.2008
131 026 131 070 131 071
131 078 131 006
131 063
131 073 131 074
Qty Wt.
131 006 O-ring 1 -

131 026 Thrust bearing bush 1 -
131 071 O-ring 1 -
131 073 O-ring 1 -
131 074 Plug 1 -
DBAE577326-
Edition: D
Page: 3(3)
Updated: 02.10.2008
View A
Section B-B
B
B
131 076
131 065
131 089
131 075
Qty Wt.
131 065 Screw 6 -

131 075 Screw 9 -
131 076 Reducing nipple 1 -
131 089 Washer 6 -
DBAE577326-
DBAE577326-
Edition: C
Page: 1(2)
Updated: 03.10.2008
Intermediate gears for camshaft drive
131 071 131 066

131 025
131 081
131 003
131 005
131 007
131 090
131 067
131 068
131 006
131 076 131 074
131 027 387 017
131 029 131 001 131 002 131 026
Qty Wt.
131 001 Bigger intermediate gear 1 113

131 002 Small intermediate gear 1 201
131 003 Bearing piece 1 29.6
131 005 Cover 1 -
131 006 O-ring 1 -
131 007 Screw 6 -
131 025 Pin 4 -
131 026 Thrust bearing bush 1 0.8
131 027 O-ring 1 -
131 029 Extension piece 1 24.5
131 066 Cover 1 33.3
131 067 Screw 1 19.3
131 068 Nut 1 5.6
131 071 O-ring 1 -
131 074 Plug 1 -
131 076 Reducing nipple 1 -
131 081 Screw 8 -
131 090 Washer 6 -
DBAE577326-
Edition: C
Page: 2(2)
Updated: 03.10.2008
Intermediate gears for camshaft drive
131 025
131 026
131 029 131 076
131 001 131 002 131 081 131 007
131 067 131 068
131 003
131 066
131 006
131 074
131 071 131 027 131 005
387 017
DBAE577326-
Edition: A
Page: 1(2)
Updated: 10.10.2000
Rocker arms and bearing bracket
143 001
143 003
A
143 002
143 010 Ex
143 014 In
143 007
A 143 008 Ex 143 012
143 013
143 009 In
Qty Wt.

bracket
143 002 Adjusting screw 2 0.4
143 003 Nut 2 -
143 007 Bearing bracket 1 9.5
143 008 Rocker arm for exhaust 1 6.0
valve
143 009 Rocker arm for inlet 1 6.4
valve
143 010 Yoke for exhaust valve, 1 -
compl.
143 012 Adjustable pin 1 -
143 013 Nut 1 -
143 014 Yoke for inlet valve, 1 -
compl.
143 012 Adjustable pin 1 -
143 013 Nut 1 -
DBAE577326-
Edition: A
Page: 2(2)
Updated: 10.10.2000
Rocker arms and bearing bracket
Section A-A
143 018
143 006
143 001
143 017
143 016
Qty Wt.

bracket
143 006 Retainer ring 1 -
143 016 Shaft 1 7.0
143 017 Plug 1 -
143 018 Screw 1 -
DBAE577326-
Edition: H
Page: 1(4)
Updated: 25.11.2008
Valve tappet with guide block
145 001
145 002
145 020
145 018
387 025 145 019
Qty Wt.
145 001 Push rod 2 -

145 002 Protecting pipe 2 -
145 018 Valve tappet 1 -
145 019 O-ring 1 -
145 020 Screw 4 -
DBAE577326-
Edition: H
Page: 2(4)
Updated: 25.11.2008
145 018
145 024
387 017
145 021
145 022 Section A-A
145 023
145 025
145 008
A
145 040
145 010
145 028 145 027
145 026
387 017
145 006
A 145 009
Qty Wt.

145 006 Pin 2 -
145 009 Tappet roller (1) 2 -
145 010 Roller pin 2 -
145 021 O-ring 2 -
145 022 Housing 1 -
145 023 Spring 2 -
145 024 Plug 1 -
145 025 Washer 2 -
145 026 Spring 2 -
145 027 Screw 2 -
145 028 Guiding plate 1 -
NOTE! (1) Bearing bush included.
DBAE577326-
Edition: H
Page: 3(4)
Updated: 25.11.2008
145 021
145 023
145 024 145 022
145 025
145 008
145 028 145 010
145 027
145 026
145 009
145 006
Qty Wt.
145 006 Pin 2 -

145 021 O-ring 2 -
145 022 Housing 1 -
145 023 Spring 2 -
145 024 Plug 1 -
145 025 Washer 2 -
145 026 Spring 2 -
145 027 Screw 2 -
145 028 Guiding plate 1 -
DBAE577326-
Edition: H
Page: 4(4)
Updated: 25.11.2008
145 021
145 008
145 009
145 030
120 003 145 010
145 026
145 006
Qty Wt.
145 030 Spare part kit 1 -

120 003 O-ring 1 -
145 006 Pin 1 -
145 021 O-ring 1 -
145 026 Spring 1 -
DBAE577326-
Edition: A
Page: 1(4)
Updated: 17.04.2012
Camshaft CWR
B-Bank
148 068
148 003 148 006
148 023 148 039
148 060
148 002 148 003 148 004 148 066
148 003 148 023 A-Bank 148 007 148 004 148 060
148 023 148 006 148 013 148 061 148 010
148 018 387 017 387 017 148 064
148 024
148 063
148 026 148 062
148 003 148 003 148 038
148 023 148 001 148 023 148 066 387 017
Qty Wt.
148 001 Camshaft piece 10 -

148 003 Snap ring 41 -
148 004 Drive gear 2 -
148 006 Screw 240 -
148 007 Nut 240 -
148 010 Gear 1 -
148 013 Screw 240 -
148 018 Screw 4 -
148 023 Guide pin 41 -
148 024 Starting air cam 1 -
148 026 Extension 1 -
148 038 Screw 4 -
148 039 Extension shaft 1 -
148 060 Nut 2 -
148 062 Indicator plate 1 -
148 063 Screw 1 -
148 064 Pin 1 -
148 066 Screw 2 -
DBAE577326-
Edition: A
Page: 2(4)
Updated: 17.04.2012
Camshaft CWR
A-Bank
148 003
148 023 148 007
148 006 148 001 148 013 148 026
148 018
148 024
148 010 148 060 148 064
148 066 148 004 148 062
148 061 148 063
Qty Wt.

148 003 Snap ring 41 -
148 006 Screw 240 -
148 007 Nut 240 -
148 010 Gear 1 -
148 013 Screw 240 -
148 018 Screw 4 -
148 023 Guide pin 41 -
148 024 Starting air cam 1 -
148 026 Extension 1 -
148 060 Nut 2 -
148 062 Indicator plate 1 -
148 063 Screw 1 -
148 064 Pin 1 -
148 066 Screw 2 -
DBAE577326-
Edition: A
Page: 3(4)
Updated: 17.04.2012
Camshaft CWR
B-Bank
148 023
148 002 148 006
148 003
148 006
148 068
148 039 148 004
148 066
148 060
Qty Wt.

148 003 Snap ring 41 -
148 006 Screw 240 -
148 023 Guide pin 41 -
148 039 Extension shaft 1 -
148 060 Nut 2 -
148 066 Screw 2 -
DBAE577326-
Edition: A
Page: 4(4)
Updated: 17.04.2012
Camshaft CWR
B-Bank
148 084 148 034 148 033 148 036 148 041
148 083 148 034 148 043 148 035 148 036
A-Bank
148 084 148 034 148 033 148 036 148 041
148 044 148 034 148 043 148 035 148 036
Qty Wt.
148 033 Bearing piece 2 -

DBAE577326-
Edition: H
Page: 1(4)
Updated: 26.10.2012
Turbocharger
156 1229
156 373
156 028
156 638
156 375
156 377
156 376 SE 518

156 374 SE 528
Qty Wt.
156 028 Turbocharger 1 -

156 373 Bearing (1) 1 -
156 374 Thrust bearing (2) 1 -
156 375 Thrust bearing (1) 1 -
156 376 Disc (2) 1 -
156 377 Bearing (2) 1 -
156 638 Cartridge ** 1 -
156 1229 Bearing (1) 1 -
SE518 Speed pick-up * 1 -
SE528 Speed pick-up * 1 -
NOTE! (1) Spare part set 156 1071 includes

items marked with (1).
NOTE! (2) Spare part set 156 1072 includes
items marked with (2).
NOTE! *) SE 518 used in L-engine and
turbocharger A. SE 528 used in
turbocharger B.
NOTE! **) See page 2.
NOTE! When ordering spare parts,
turbocharger serial number and
specification must be given.
DBAE577326-
Edition: H
Page: 2(4)
Updated: 26.10.2012
Turbocharger
156 638
Qty Wt.
156 638 Cartridge 1 -
NOTE! Only spare part sets (156 379, 156

380, 156 1071, 156 1072), cartridge
(156 638) and speed pick-ups (SE
518, SE 528) for turbocharger can
be ordered.
DBAE577326-
Edition: H
Page: 3(4)
Updated: 26.10.2012
Turbocharger
156 379 156 380
Qty Wt.
156 379 Spare part kit (1)* 1 -

156 380 Spare part kit (2)* 1 -
NOTE! (1) Spare part set for turbine/

compressor check.
NOTE! (2) Spare part set for bearing
inspection.
NOTE! *) Content of the set depends on
turbocharger type.
380, 156 1071, 156 1072), cartridge
be ordered.
DBAE577326-
Edition: H
Page: 4(4)
Updated: 26.10.2012
Turbocharger
156 1071 156 1072
156 377
156 375 156 376
156 1229
156 373 156 374
Qty Wt.

156 373 Bearing 1 -
156 1229 Bearing 1 -
156 376 Disc 1 -
156 377 Bearing 1 -

380, 156 1071, 156 1072), cartridge
be ordered.
DBAE577326-
Edition: B
Page: 1(1)
Updated: 08.04.1999
Speed pickup for TC
ITEM X
SE 518
SE 528
156 382
Qty Wt.
156 382 Cable 1 -

SE518 Speed pick-up (1) 1 -
SE528 Speed pick-up (1) 1 -
NOTE! (1) SE 518 used in turbocharger A,

SE 528 used in turbocharger B
DBAE577326-
DBAE577326-
Edition: B
Page: 1(3)
Updated: 02.11.2009
Vibration measurements points
(1)
156 444
156 648
(2)
156 444
156 648
Qty Wt.
156 444 Measuring cube * -

156 648 Screw * -
NOTE! (1) With air suction branch

NOTE! (2) With axial air housing
NOTE! * See page 3.
DBAE577326-
Edition: B
Page: 2(3)
Updated: 02.11.2009
(3)
156 647
156 648
156 444
156 648
Qty Wt.

156 648 Screw * -
NOTE! (3) With silencer

NOTE! * See page 3.
DBAE577326-
Edition: B
Page: 3(3)
Updated: 02.11.2009

Air suction Axial air With
branch housing silencer
156 444 Measuring cube 2 1 1
156 647 Measuring cube - - 1
156 648 Screw 2 1 2
DBAE577326-
DBAE577326-
Edition: B
Page: 1(1)
Updated: 18.01.2008
Cooling air pipe for TC impeller
156 824
156 825
156 886
156 896 156 885
156 897 156 884 156 824
156 889 156 885 156 825

156 893
156 891
156 894
156 892
156 895
156 883 156 887
156 821 156 889 156 896
156 890 156 888 156 897

Qty Wt.

156 824 Screw 8 -
156 825 O-ring 2 -
156 883 Pipe 1 -
156 886 Pipe 1 -
156 887 Pipe 1 -
156 888 Support 1 -
156 889 Washer 2 -
156 890 Screw 1 -
156 892 Screw 1 -
156 894 Screw 2 -
156 895 Nut 2 -
156 897 Screw 2 -
DBAE577326-
DBAE577326-
Edition: A
Page: 1(1)
Updated: 17.12.2007
Drain pipe from receiver
156 495
156 615
156 616 156 494
156 615
156 616
156 899
156 900
156 898
Qty Wt.
156 494 Pipe 1 -

156 616 Screw 5 -
156 899 Support 2 -
156 900 Screw 2 -
DBAE577326-
DBAE577326-
Edition: C
Page: 1(6)
Updated: 01.03.2013
Charge air system
156 986 156 987
156 988
156 119
156 120
156 556
156 559
156 128
156 557
156 559
156 534
156 815 156 542 156 127 156 126
156 535 156 555 156 557 156 557
156 559 156 559 156 559
Qty Wt.
156 119 Screw 16 -

156 120 Washer 16 -
156 126 Cover 1 -
156 127 Cover 1 -
156 128 Cover 1 -
156 534 Nut 22 -
156 535 Screw 20 -
156 542 Cover 1 -
156 555 Screw 1 -
156 556 Screw 3 -
156 557 Screw 43 -
156 559 Washer 49 -
156 815 Screw 26 -
156 987 Screw 7 -
156 988 Washer 7 -
DBAE577326-
Edition: C
Page: 2(6)
Updated: 01.03.2013
Charge air system
156 538
156 558 156 533
156 840 156 534
156 841 156 184

156 119
156 039
156 120
156 535
156 541
156 557
156 559 156 158
156 553 156 537 156 815 156 534 156 534
156 557 156 536 156 1218 156 2247
156 2247
156 559
Qty Wt.
156 039 O-ring 2 -

156 119 Screw 16 -
156 120 Washer 16 -
156 158 Bracket 1 -
156 184 O-ring 2 -
156 533 Screw 18 -
156 534 Nut 22 -
156 535 Screw 20 -
156 536 Bottom plate 1 -
156 1218 Slide surface 4 -
156 537 Air duct 1 -
156 538 Screw 8 -
156 541 Cover 1 -
156 553 Cover 1 -
156 557 Screw 43 -
156 558 Screw 62 -
156 559 Washer 49 -
156 815 Screw 26 -
156 840 Plug 1 -
156 2247 Screw 4 -
DBAE577326-
Edition: C
Page: 3(6)
Updated: 01.03.2013
Charge air system
156 557
156 559
B
156 625 B
Qty Wt.
156 557 Screw 43 -

156 559 Washer 49 -
156 625 Cover 1 -
DBAE577326-
Edition: C
Page: 4(6)
Updated: 01.03.2013
Charge air system
View A
A
Section B-B
156 554
156 559
156 110
156 034
156 026
387 025
156 131
156 560
387 025 A
156 549
Qty Wt.
156 026 Bellows 2 -

156 034 Screw 16 -
156 110 Nut 16 -
156 131 Nut 16 -
156 549 Air duct 1 -
156 554 Screw 2 -
156 559 Washer 49 -
156 560 Screw 8 -
DBAE577326-
Edition: C
Page: 5(6)
Updated: 01.03.2013
Charge air system
Section A-A
156 543 156 563
156 544
156 550
156 539 156 119
156 131
156 546
156 560
156 559
156 131
156 558
156 904
156 545
387 025
Qty Wt.
156 119 Screw 16 -

156 131 Nut 16 -
156 539 Screw 14 -
156 543 Support 2 -
156 544 Screw 6 -
156 545 Support 1 -
156 546 Support 1 -
156 550 Air duct 1 -
156 558 Screw 62 -
156 559 Washer 49 -
156 560 Screw 8 -
156 563 Screw 6 -
156 904 Screw 8 -
DBAE577326-
Edition: C
Page: 6(6)
Updated: 01.03.2013
Charge air system
156 708
156 707
156 544
156 705
156 547
156 548
156 539 156 538 156 706
Qty Wt.
156 538 Screw 8 -

156 539 Screw 14 -
156 544 Screw 6 -
156 547 Washer 6 -
156 548 Nut 6 -
156 705 Pin 4 -
156 706 Screw 8 -
156 707 Screw 4 -
156 708 Screw 4 -
DBAE577326-
Edition: B
Page: 1(1)
Updated: 04.04.2011
Covers for air duct
156 2262
156 2261 156 993
156 2263
156 937 156 990 156 991
156 556 156 989 156 992
156 559 156 112
156 587 156 391
156 939 156 130
156 554 387 025
156 559
156 551
Qty Wt.
156 112 Screw 8 -

156 130 Flange 1 -
156 391 Washer 8 -
156 551 Cover 1 -
156 554 Screw 9 -
156 556 Screw 2 -
156 559 Washer 11 -
156 587 Screw 7 -
156 937 Cover 1 -
156 939 Washer 7 -
156 989 Cover 1 -
156 990 Cover 1 -
156 991 Screw 1 -
156 992 Washer 1 -
156 993 Screw 2 -
156 2261 Flange 1 -
156 2262 Washer 2 -
156 2263 Screw 2 -
DBAE577326-
DBAE577326-
Edition: A
Page: 1(2)
Updated: 24.09.2013
Pulsation damper
156 712 156 2269
Qty Wt.
156 712 Pulsation damper 1 77.0

156 2269 Bracket 9 7.2
DBAE577326-
Edition: A
Page: 2(2)
Updated: 24.09.2013
Pulsation damper
156 714
156 713
387 017
156 281
156 2269
156 1333
156 715
156 282 387 017
387 006
Qty Wt.
156 2269 Bracket 1 7.2

156 281 Screw 2 0.1
156 282 Nut 2 -
156 713 Pipe clamp 1 6.0
156 714 Screw 2 -
156 715 Screw 2 0.4
156 1333 O-ring 2 -
DBAE577326-
Edition: A
Page: 1(2)
Updated: 25.06.2014
Drain pipe in flywheel end
DBAE577326-
Edition: A
Page: 2(2)
Updated: 25.06.2014
Drain pipe in flywheel end
156 2452 156 2452
156 2458
156 2461
387 003
156 2452
156 2458
156 2460
387 003
156 2452
156 2456
156 2458
156 2459
387 003
Qty Wt.
156 2452 Cover plate 6 0.1

156 2456 Pipe 1 0.6
156 2458 Pipe clamp 4 -
156 2459 Screw 4 -
156 2460 Screw 2 -
156 2461 Screw 2 -
DBAE577326-
Edition: A
Page: 1(1)
Updated: 25.06.2014
Drain pipe in free end
156 2457
156 2452
156 2458
156 2459
387 003
Qty Wt.
156 2452 Cover plate 2 0.1

156 2457 Pipe 1 0.5
156 2458 Pipe clamp 2 -
156 2459 Screw 4 -
DBAE577326-
DBAE577326-
Edition: A
Page: 1(2)
Updated: 26.10.2016
DBAE577326-
Edition: A
Page: 2(2)
Updated: 26.10.2016
A
156 1120
156 1113
156 1111 156 1129

156 2324
156 1124
156 1125 156 1118 156 1122
156 1128
156 2446 156 1109 156 1129 156 1117
156 1130
156 2499 156 2502 156 1111
156 2507
156 2509
156 1119
156 1128 156 1120

156 2504
156 2326 156 1124 156 1113
156 2505
156 2500 156 2446 156 1128
156 2503 156 2507 156 1130
156 2506 156 2507
156 2451 156 2501 156 2508
156 2502 387 003
Qty Wt. Qty Wt.

156 1109 Pipe union 1 0.4 156 2505 Pipe union 2 0.1
156 1111 Pipe union 2 0.1 156 2506 Washer 1 -
156 1113 Pipe union 2 0.1 156 2507 Washer 4 -
156 1117 Pipe 1 0.4 156 2508 Screw 1 -
156 1118 Pipe 1 0.2 156 2509 Screw 1 -
156 1120 Pipe 2 0.1
156 1122 Support 2 0.2
156 1124 Pipe clamp 6 -
156 1125 Screw 1 -
156 1128 Nut 4 -
156 1129 Screw 3 -
156 1130 Screw 3 -
156 2324 Support 1 0.2
156 2326 Screw 1 -
156 2446 Pipe clamp 2 -
156 2451 Pipe union 1 0.2
156 2499 Support 1 0.2
156 2500 Support 1 0.4
156 2501 Pipe 1 0.1
156 2502 Reduction union 3 0.2
156 2503 Distance sleeve 1 -
156 2504 Valve 1 0.7
DBAE577326-
Edition: D
Page: 1(3)
Updated: 27.06.2016
Lifter for injection pump
161 016
161 022 161 001
161 009
161 006
161 011 350 125 *

161 012
161 015
161 008
161 007
161 002
161 023
161 003
387 020
161 004
161 020
161 014
Qty Wt.
161 001 Lifter, compl. 1 -

161 002 Tappet 1 5.6
161 003 Roller pin 1 0.8
161 004 Tappet roller 1 2.2
161 006 Screw 1 0.7
161 007 Securing plate 1 0.3
161 008 Washer 1 0.1
161 009 Spring 1 1.6
161 011 Screw 2 -
161 012 O-ring 2 0.1
161 014 O-ring 1 -
161 015 Sleeve 2 -
161 016 Housing 1 31.0
161 022 O-ring 1 0.1
161 023 Screw 1 0.4
161 020 Screw 2 -
350 125 O-ring * 2 -
NOTE! *) See 350-
DBAE577326-
Edition: D
Page: 2(3)
Updated: 27.06.2016
161 009
161 022
161 008
161 006 161 002
161 003
161 011
161 004
161 015 161 023

161 016
161 012
161 007 161 012
Qty Wt.
161 002 Tappet 1 5.6

161 003 Roller pin 1 0.8
161 004 Tappet roller 1 2.2
161 006 Screw 1 0.7
161 008 Washer 1 0.1
161 009 Spring 1 1.6
161 011 Screw 2 -
161 012 O-ring 2 0.1
161 015 Sleeve 2 -
161 016 Housing 1 31.0
161 022 O-ring 1 0.1
161 023 Screw 1 0.4
DBAE577326-
Edition: D
Page: 3(3)
Updated: 27.06.2016
161 021
350 125 * 161 014
161 012 161 022
Qty Wt.

161 012 O-ring 2 0.1
161 014 O-ring 1 -
161 022 O-ring 1 0.1
350 125 O-ring * 2 -
NOTE! *) Use the square type seal ring with

a chamfered sleeve, which can be
identified with 3 grooves on the outer
surface.
DBAE577326-
DBAE577326-
Edition: G
Page: 1(8)
Updated: 27.06.2016
Injection pump
165 058
165 002
165 059
165 083 165 024
165 053 165 132
A 165 088
165 008 165 084
165 025 165 037
165 023 165 010
165 085 165 061 165 001
165 086 165 062
165 011 * 165 067
165 029 165 054 *
165 063 *
165 017 *
165 064 *
165 055 *
165 074
165 057 * 165 071 165 066 165 065

Qty Wt. Qty Wt.
165 001 Injection pump 1 - 165 084 Support ring (1) 2 -

165 002 Screw 6 0.1 165 085 Plug 1 -
165 008 Erosion plug 2 0.2 165 086 Sealing ring 1 -
165 010 Plug 1 - 165 088 Seal (1) 1 -
165 011 Spring plate * 1 - 165 132 Steel wire 2 -
165 017 Spring * 1 -
165 023 Pump element 1 6.5 NOTE! (2) An updated design exists where
165 024 Sealing ring 1 - only four screws are required.
165 025 Sealing ring 2 - NOTE! * See page 7.
165 029 Control sleeve 1 0.6 NOTE! Spare parts marked (1) cannot be
165 067 Pin 1 - ordered separately.
165 037 Fuel rack 1 0.4 NOTE! Spare parts marked * cannot be
165 053 Screw 2 - ordered separately. Only as a set
165 054 Holder * 1 - 165 119.
165 055 Retaining ring * 1 -
165 057 Screw * (2) 6 -
165 058 Screw 8 -
165 059 Pump cover 1 6.9
165 062 O-ring 1 -
165 063 Snap ring * 1 -
165 064 O-ring * 1 -
165 065 Flange (2) 1 2.3
165 066 Push rod 1 0.7
165 074 O-ring 1 -
165 083 Pin 1 -
DBAE577326-
Edition: G
Page: 2(8)
Updated: 27.06.2016
Injection pump
165 084
165 002
165 024 165 088 165 011 *
165 084
165 058 165 083
165 017 *
165 053
165 059
165 008 165 061 165 054 *
165 025 165 055 *

165 062 165 063 *
165 085
165 023
165 010
165 086
165 066
165 064 *
165 029 165 074

165 071
165 067
165 065
165 057 *
Qty Wt. Qty Wt.

165 002 Screw 6 0.1 165 074 O-ring 1 -

165 008 Erosion plug 2 0.2 165 083 Pin 1 -
165 010 Plug 1 - 165 084 Support ring (1) 2 -
165 011 Spring plate * 1 - 165 085 Plug 1 -
165 017 Spring * 1 - 165 086 Sealing ring 1 -
165 023 Pump element 1 6.5 165 088 Seal (1) 1 -
165 025 Sealing ring 2 - NOTE! (2) An updated design exists where
165 029 Control sleeve 1 0.6 only four screws are required.
165 067 Pin 1 - NOTE! * See page 7.
165 053 Screw 2 - NOTE! Spare parts marked (1) cannot be
ordered separately.
165 054 Holder * 1 -
NOTE! Spare parts marked * cannot be
ordered separately. Only as a set
165 057 Screw * (2) 6 - 165 119.
165 058 Screw 8 -
165 059 Pump cover 1 6.9
165 062 O-ring 1 -
165 063 Snap ring * 1 -
165 064 O-ring * 1 -
165 065 Flange (2) 1 2.3
165 066 Push rod 1 0.7
DBAE577326-
Edition: G
Page: 3(8)
Updated: 27.06.2016
Injection pump
165 083 165 024
165 053
165 088
165 132
165 084
165 008
165 062
165 025
165 023
165 010
165 085
165 061
165 086
165 029 165 067 165 037
Qty Wt.
165 008 Erosion plug 2 0.2

165 010 Plug 1 -
165 023 Pump element 1 6.5
165 029 Control sleeve 1 0.6
165 067 Pin 1 -
165 037 Fuel rack 1 0.4
165 053 Screw 2 -
165 062 O-ring 1 -
165 083 Pin 1 -
165 084 Support ring (1) 2 -
165 085 Plug 1 -
165 088 Seal (1) 1 -
165 132 Steel wire 2 -
NOTE! Spare parts marked (1) cannot be

ordered separately.
DBAE577326-
Edition: G
Page: 4(8)
Updated: 27.06.2016
Injection pump
165 075
165 059 165 001
165 013
165 068 165 078
165 076
165 037
165 077
165 072
165 073
350 125
Qty Wt.
165 001 Injection pump 1 -

165 013 Sleeve 2 1.0
165 037 Fuel rack 1 0.4
165 072 Plate 1 -
165 073 Screw 2 -
165 059 Pump cover 1 6.9
165 068 Pin 1 -
165 076 Valve *) 1 -
165 078 Valve cone *) 1 -
165 075 Spring 1 -
165 077 Spring 1 -
350 125 O-ring 4 -
NOTE! *) 165 076 and 165 078 are

delivered only with complete pump
cover 165 059
DBAE577326-
Edition: G
Page: 5(8)
Updated: 27.06.2016
Injection pump
165 059
165 078
165 068
165 075
165 076 165 077
Qty Wt.
165 059 Pump cover 1 6.9

165 068 Pin 1 -
165 076 Valve *) 1 -
165 078 Valve cone *) 1 -
165 075 Spring 1 -
165 077 Spring 1 -
NOTE! *) 165 076 and 165 078 are

delivered only with complete pump
cover 165 059
DBAE577326-
Edition: G
Page: 6(8)
Updated: 27.06.2016
Injection pump
228 011
Qty Wt.
228 011 Sleeve 1 -
DBAE577326-
Edition: G
Page: 7(8)
Updated: 27.06.2016
Injection pump
165 064 * 165 011 * 165 057 * 165 017 *
165 119
165 054 * 165 055 * 165 063 *
Qty Wt.
165 119 Spring assembly 1 1.8

165 017 Spring * 1 -
165 054 Holder * 1 -
165 057 Screw * 6 -
165 063 Snap ring * 1 -
165 064 O-ring * 1 -
NOTE! Spare parts marked * cannot be

ordered separately. Only as a set
165 119.
DBAE577326-
Edition: G
Page: 8(8)
Updated: 27.06.2016
Injection pump
165 080
161 012 161 014 165 061
165 074
* 350 125
165 062
165 064
358 023 165 024
165 025
165 008 165 084
350 134 *
165 088
165 071
358 022
165 132
Qty Wt.
165 080 Sealing set 1 0.5

161 012 O-ring 2 0.1
161 014 O-ring 1 -
165 008 Erosion plug 2 0.2
165 062 O-ring 1 -
165 064 O-ring 1 -
165 074 O-ring 1 -
165 084 Support ring (1) 2 -
165 088 Seal (1) 1 -
165 132 Steel wire 2 -
350 125 O-ring * 4 -
350 134 O-ring * 4 -
358 022 O-ring 5 -
358 023 O-ring 4 -
NOTE! *) Use the square type seal ring with

a chamfered sleeve, which can be
identified with 3 grooves on the outer
surface.
NOTE! Spare parts marked (1) cannot be
ordered separately.
DBAE577326-
Edition: B
Page: 1(4)
Updated: 08.06.2017
Injection valve
167 046
167 005
167 020
Qty Wt.

167 020 Nozzle 1 0.2
167 046 Nozzle holder 1 -
DBAE577326-
Edition: B
Page: 2(4)
Updated: 08.06.2017
Injection valve
167 050 167 057
167 053 167 011
167 018 167 193
167 052 167 047
167 014 167 051 167 046
167 013 167 048
167 021
167 017
Qty Wt.
167 046 Nozzle holder 1 -

167 011 O-ring 1 -
167 013 Push rod 1 -
167 014 Spring 1 0.2
167 017 Nozzle nut 1 -
167 021 Pin 2 -
167 047 O-ring 1 -
167 048 O-ring 1 -
167 050 Nut 1 -
167 051 Screw 1 -
167 052 Spring retainer 1 0.3
167 053 O-ring 1 -
167 057 Pin 1 -
167 193 O-ring 1 0.2
DBAE577326-
Edition: B
Page: 3(4)
Updated: 08.06.2017
Injection valve
167 050 167 057
167 018 167 014 167 051
167 011
167 053 167 013
167 193
167 047
167 052
167 048
167 017
167 021
Qty Wt.
167 011 O-ring 1 -

167 013 Push rod 1 -
167 014 Spring 1 0.2
167 017 Nozzle nut 1 -
167 021 Pin 2 -
167 047 O-ring 1 -
167 048 O-ring 1 -
167 050 Nut 1 -
167 051 Screw 1 -
167 052 Spring retainer 1 0.3
167 053 O-ring 1 -
167 057 Pin 1 -
167 193 O-ring 1 0.2
DBAE577326-
Edition: B
Page: 4(4)
Updated: 08.06.2017
Injection valve
167 048 167 001
167 047
167 053
167 044
167 060
167 193
167 011
Qty Wt.
167 044 Sealing set for injection 1 -

valve
167 001 O-ring 1 -
167 011 O-ring 1 -
167 047 O-ring 1 -
167 048 O-ring 1 -
167 053 O-ring 1 -
167 193 O-ring 1 0.2
DBAE577326-
Edition: A
Page: 1(2)
Updated: 10.03.2011
Injection valve equipment
167 007
167 049
167 006
167 008
167 058
167 060
167 011
167 193
167 003
167 047
167 059
167 048
167 001
167 005
Qty Wt.
167 001 O-ring 1 -

167 005 Injection valve 1 10.8
167 006 Yoke 1 2.8
167 007 Nut 2 0.1
167 008 Screw 2 -
167 011 O-ring 1 -
167 047 O-ring 1 -
167 048 O-ring 1 -
167 049 Distance piece 2 -
167 058 Flange 1 -
167 059 Flange 1 -
167 193 O-ring 1 0.2
DBAE577326-
Edition: A
Page: 2(2)
Updated: 10.03.2011
Injection valve equipment
167 007
167 049
167 059 167 001

167 006
167 008
167 003 167 060 167 058
167 011
167 193
167 005 167 047
167 048
Qty Wt.
167 001 O-ring 1 -

167 005 Injection valve 1 10.8
167 011 O-ring 1 -
167 047 O-ring 1 -
167 048 O-ring 1 -
167 193 O-ring 1 0.2
167 006 Yoke 1 2.8
167 007 Nut 2 0.1
167 008 Screw 2 -
167 058 Flange 1 -
167 059 Flange 1 -
DBAE577326-
Edition: A
Page: 1(1)
Updated: 21.04.2008
Lubricating oil pump
181 001
See 181-
181 006
181 292
Qty Wt.

181 292 Clamping ring 1 -
DBAE577326-
DBAE577326-
Edition: B
Page: 1(4)
Updated: 05.03.2014
181 001
A-A
A
181 013 181 023 181 058 181 061 181 063 181 064
B
181 059 181 020
181 025 A
181 065
181 026
181 068
181 069
181 022
181 021
181 060
181 067
181 062
C 181 066
181 011
181 076 181 010 C

Qty Wt. Qty Wt.
181 001 Lubricating oil pump 1 - NOTE! (3) Included in Spindle set 181 079
181 010 Drive shaft (3) 1 80.0
181 011 Cover 1 -
181 013 Screw 9 -
181 020 Piston (2) 1 -
181 021 Compression spring (2) 1 -
181 022 Spring holder (2) 1 -
181 023 O-ring (2) 1 -
181 025 Screw (2) 1 -
181 026 Nut (2) 1 -
181 058 Screw (1) (2) 6 -
181 059 Sealing ring (1) (2) 6 -
181 060 Valve cone (2) 1 -
181 061 Cylindrical pin (2) 1 -
181 062 Valve sleeve (2) 1 -
181 063 O-ring (2) 2 -
181 064 Non-return valve (2) 1 -
181 065 Circlip (2) 1 -
181 066 Circlip (1) 1 0.2
181 067 Circlip (1) 1 -
181 068 Spacer ring 1 -
181 069 Ball bearing (1) 1 5.0
181 076 Gasket (2) 1 -
NOTE! (1) Included in Service kit 181 077

NOTE! (2) Included in Valve kit 181 078
DBAE577326-
Edition: B
Page: 2(4)
Updated: 05.03.2014
181 023 181 021 181 060 181 061 181 063 181 062 181 020 181 065
181 022
181 013 181 064 181 059
181 058
181 068
181 069
181 025
181 026
181 011
181 076 181 010 181 066 181 067

Qty Wt. Qty Wt.
181 010 Drive shaft (3) 1 80.0 NOTE! (1) Included in Service kit 181 077
181 011 Cover 1 - NOTE! (2) Included in Valve kit 181 078
181 013 Screw 9 - NOTE! (3) Included in Spindle set 181 079
181 020 Piston (2) 1 -
181 021 Compression spring (2) 1 -
181 022 Spring holder (2) 1 -
181 023 O-ring (2) 1 -
181 025 Screw (2) 1 -
181 026 Nut (2) 1 -
181 058 Screw (1) (2) 6 -
181 059 Sealing ring (1) (2) 6 -
181 060 Valve cone (2) 1 -
181 061 Cylindrical pin (2) 1 -
181 062 Valve sleeve (2) 1 -
181 063 O-ring (2) 2 -
181 064 Non-return valve (2) 1 -
181 065 Circlip (2) 1 -
181 066 Circlip (1) 1 0.2
181 067 Circlip (1) 1 -
181 068 Spacer ring 1 -
181 069 Ball bearing (1) 1 5.0
181 076 Gasket (2) 1 -
DBAE577326-
Edition: B
Page: 3(4)
Updated: 05.03.2014
181 005
181 070 181 058 181 072 181 075
181 059 181 073
C-C
Qty Wt.
181 005 Drive shaft (3) 2 30.0

181 058 Screw (1) (2) 6 -
181 059 Sealing ring (1) (2) 6 -
181 070 Threaded pin (2) 1 -
181 072 Non-return valve 1 0.5
181 073 Gasket 2 -
181 075 Threaded pin 1 -
NOTE! (1) Included in Service kit 181 077

NOTE! (2) Included in Valve kit 181 078
NOTE! (3) Included in Spindle set 181 079
DBAE577326-
Edition: B
Page: 4(4)
Updated: 05.03.2014
181 077 181 078
181 079
Qty Wt.
181 077 Service kit 1 -

181 078 Valve kit 1 -
181 079 Spindle set 1 140
DBAE577326-
Edition: B
Page: 1(2)
Updated: 26.08.2008
Prelubricating oil pump
182 015
182 018
182 005
182 150
387 017
182 151
182 147
387 017
Qty Wt.
182 005 Screw 6 -

182 015 Electrical motor 1 -
182 018 Prelubricating oil pump 1 -
(1)
182 147 Screw 1 -
182 150 Pin 2 -
182 151 Pin 2 -
NOTE! (1) See 182-
DBAE577326-
Edition: B
Page: 2(2)
Updated: 26.08.2008
View A
182 016
387 017
182 017
182 149
182 152
387 017
182 148
387 017
Qty Wt.
182 016 Screw 4 -

182 017 Flexible coupling 1 -
182 148 Screw 3 -
182 149 Screw 2 -
182 152 Key 1 -
DBAE577326-
Edition: B
Page: 1(3)
Updated: 31.01.2012
182 164
182 165
182 018
Qty Wt.
182 018 Prelubricating oil pump 1 106

182 164 Cover 2 -
182 165 Screw 4 -
DBAE577326-
Edition: B
Page: 2(3)
Updated: 31.01.2012
View A
B
182 029
182 020
B
Qty Wt.
182 020 Key 1 -

182 029 Screw 4 0.3
DBAE577326-
Edition: B
Page: 3(3)
Updated: 31.01.2012
Section B - B
182 020
182 023
182 166
182 029
182 167
182 027
182 024
182 025
182 026
182 038
Qty Wt.
182 020 Key 1 -

182 023 Seal (2) 1 -
182 024 Pin 2 -
182 025 Gear shaft 1 5.6
182 026 Drive gear shaft 1 6.5
182 027 O-ring (2) 1 -
182 029 Screw 4 0.3
182 062 Sealing set (1) 1 -
182 167 Shim ring 1 -
NOTE! (1) Sealing set includes items

marked (2)
DBAE577326-
DBAE577326-
Edition: A
Page: 1(1)
Updated: 16.01.2013
Thermostatic element assembly
183 005 183 088 183 089
183 086
183 003
Qty Wt.
183 086 Thermostatic element 5 -

assembly
183 003 Thermostatic element 1 0.7
183 005 O-ring 1 -
183 088 O-ring (1) 1 -
183 089 Retaining ring (1) 1 -
183 087 Service kit 1 0.5
183 005 O-ring 1 -
183 088 O-ring (1) 1 -
183 089 Retaining ring (1) 1 -
NOTE! (1) Parts available only in service kit.
DBAE577326-
DBAE577326-
Edition: A
Page: 1(2)
Updated: 14.05.2013
Oil dipstick
184 004
184 005
184 006
Qty Wt.
184 004 Protecting pipe 1 0.5

184 005 Screw 2 -
184 006 Pipe clamp 2 0.4
DBAE577326-
Edition: A
Page: 2(2)
Updated: 14.05.2013
Oil dipstick
A-A
A
184 001
184 016
184 018
184 017
A
Qty Wt.
184 001 Dipstick 1 0.2

184 016 Nut 1 0.1
184 017 Pipe union 1 0.1
184 018 Cutting ring 1 -
DBAE577326-
Edition: F
Page: 1(5)
Updated: 04.10.2016
Water pump
191 009 191 052
191 001
A
191 002
191 052 191 009
Qty Wt.

191 009 Plug 2 0.2
191 052 Plug 3 -
DBAE577326-
Edition: F
Page: 2(5)
Updated: 04.10.2016
Water pump
A-A 191 052
191 051 191 112
191 056
191 055
191 106 191 013

191 019
191 103 191 054
* 191 012 191 018
191 006 191 015
191 016
191 005
191 017
191 007
191 053 191 063
191 003 191 043 191 094

Qty Wt. Qty Wt.
191 003 O-ring (1) 1 -

191 005 Washer 1 - NOTE! (1) The part is included in the sealing
191 006 Screw 2 - kit, it is not sold as separate spare
part.
191 007 Shaft seal (1) 1 -
NOTE! (2) When ordering the pump shaft,
191 012 Bearing 1 - please use SPN 191112 Pump shaft
191 013 Bearing 1 - replacement set, the sealing kit (with
191 015 Screw (1) 4 - needed seals for replacement) will
191 016 Pressure plate 1 - be delivered with the shaft.
191 017 Pair of friction rings 2 - NOTE! *) Impeller, see page 4.
191 018 Drive gear wheel 1 -
191 019 Clamp ring 1 -
191 043 Chamber 1 28.5
191 052 Plug 3 -
191 053 Shield plug 4 0.2
191 055 Housing 1 36.0
191 063 Bearing housing 1 20.0
191 103 Shaft seal (1) 1 -
191 106 Plug 1 0.2
191 112 Pump shaft replacement 1 -
set (2)
191 051 Sealing kit 1 -
191 056 Shaft (2) 1 -
DBAE577326-
Edition: F
Page: 3(5)
Updated: 04.10.2016
Water pump
191 052
191 055
191 006 * 191 007 191 043
191 019 191 003 191 005
191 106 191 112 191 051 191 054 191 017 191 015
191 103 191 056
191 094 191 053 191 063 191 012 191 013 191 018 191 016
Qty Wt. Qty Wt.
191 003 O-ring (1) 1 -

191 005 Washer 1 - NOTE! (1) The part is included in the sealing
191 006 Screw 2 - kit, it is not sold as separate spare
part.
191 007 Shaft seal (1) 1 -
NOTE! (2) When ordering the pump shaft,
191 012 Bearing 1 - please use SPN 191112 Pump shaft
191 013 Bearing 1 - replacement set, the sealing kit (with
191 015 Screw (1) 4 - needed seals for replacement) will
191 016 Pressure plate 1 - be delivered with the shaft.
191 017 Pair of friction rings 2 - NOTE! *) Impeller, see page 4.
191 018 Drive gear wheel 1 -
191 043 Chamber 1 28.5
191 052 Plug 3 -
191 053 Shield plug 4 0.2
191 055 Housing 1 36.0
191 103 Shaft seal (1) 1 -
191 106 Plug 1 0.2
191 112 Pump shaft replacement 1 -
set (2)
191 056 Shaft (2) 1 -
DBAE577326-
Edition: F
Page: 4(5)
Updated: 04.10.2016
Water pump
PART NUMBER SELECTION TABLE FOR IMPELLER

When ordering impeller, choose the right part number for the pump type
(found from the type plate on the pump) according to the table below.
Impeller Impeller
Part No Pump type No Ø Qty
191 095 CNW-46/32L183 183 1

191 107 CNW-46/32L194 194 1
191 097 CNW-46/32L197 197 1
191 098 CNW-46/32L210 210 1
191 109 CNW-46/32L220 220 1
191 099 CNW-46/32R183 183 1
191 108 CNW-46/32R194 194 1
191 101 CNW-46/32R197 197 1
191 102 CNW-46/32R210 210 1
191 110 CNW-46/32R220 220 1
Qty Wt.
NOTE! Pump type can also be marked as

CNW-32/46.
DBAE577326-
Edition: F
Page: 5(5)
Updated: 04.10.2016
Water pump
191 003
107 177
191 015
107 064
191 051
191 103
191 007
Qty Wt.

107 064 O-ring 1 -
107 177 O-ring 1 -
191 003 O-ring (1) 1 -
191 007 Shaft seal (1) 1 -
191 015 Screw (1) 4 -
191 103 Shaft seal (1) 1 -
NOTE! (1) The part is included in the sealing

kit, it is not sold as separate spare
part.
DBAE577326-
DBAE577326-
Edition: C
Page: 1(1)
Updated: 18.02.2004
Connection piece for water system
196 276 196 285
196 021
196 013
196 415
196 018
196 416
196 283
196 279
196 284
HT
196 042
196 043
196 417
196 281
LT
Qty Wt.
196 283 Connection piece (1) 1 -

196 013 Cover 1 -
196 018 Screw 11 -
196 021 O-ring 1 -
196 042 Plug 1 -
196 276 Housing 1 -
196 279 Screw 4 -
196 281 Bend 1 -
196 284 Connection piece (2) 1 -
196 021 O-ring 1 -
196 042 Plug 1 -
196 276 Housing 1 -
196 279 Screw 4 -
196 415 Cover 1 -
196 416 Screw 11 -
196 417 Bend 1 -
196 285 Throttle ring 1 -
NOTE! (1) LT-side

NOTE! (2) HT-side
DBAE577326-
DBAE577326-
Edition: A
Page: 1(2)
Updated: 28.03.2008
Connection piece for LT-water
196 418
A
196 285
196 018
387 017
196 013
196 283
Qty Wt.
196 283 Connection piece 1 -

196 013 Cover 1 -
196 018 Screw 5 -
196 418 Housing 1 -
196 285 Throttle ring 1 -
DBAE577326-
Edition: A
Page: 2(2)
Updated: 28.03.2008
Connection piece for LT-water
Section A - A
196 422
196 423
Qty Wt.
196 422 O-ring 1 -

196 423 Pin 2 -
DBAE577326-
Edition: A
Page: 1(2)
Updated: 31.03.2008
Cooling water pipes
196 431
196 429
196 430
Qty Wt.
196 429 O-ring 3 -

196 430 Plug 3 -
196 431 O-ring 3 -
DBAE577326-
Edition: A
Page: 2(2)
Updated: 31.03.2008
Cooling water pipes
View A
196 431
196 426
387 017
196 428 196 425

387 017
196 424
196 429
196 430
196 427
196 431 196 429
387 017
196 430
Qty Wt.
196 424 Water pipe 1 -

196 426 Screw 4 -
196 427 Screw 4 -
196 428 Screw 4 -
196 429 O-ring 3 -
196 430 Plug 3 -
196 431 O-ring 3 -
DBAE577326-
Edition: B
Page: 1(2)
Updated: 13.01.2010
Exhaust system
200 076 200 029 200 079
200 009 200 003

200 011
200 017 200 020

200 028
Qty Wt.
200 003 Exhaust pipe * -

200 009 Screw * -
200 011 Nut * -
200 017 Screw * -
200 020 Distance piece * -
200 029 Gasket * -
200 079 Bellows * -
NOTE! * See page 2
DBAE577326-
Edition: B
Page: 2(2)
Updated: 13.01.2010
Exhaust system

12V 16V 18V 20V
200 003 Exhaust pipe 10 16 18 20
200 009 Screw 120 180 204 228
200 011 Nut 120 180 204 228
200 017 Screw 40 64 72 80
200 020 Distance piece 40 64 72 80
200 028 Sealing ring 10 16 18 20
200 029 Gasket 20 30 34 38
200 079 Bellows 10 14 16 16
DBAE577326-
Edition: A
Page: 1(1)
Updated: 28.05.2007
Connection piece for exhaust gas
200 009
200 084 200 078 200 011 200 077
200 085
200 081
200 080
Qty Wt.
200 009 Screw 12 -

200 011 Nut 12 -
200 081 Bellows 2 3.8
200 084 Screw 32 0.1
200 085 Nut 32 -
DBAE577326-
DBAE577326-
Edition: A
Page: 1(3)
Updated: 13.04.2010
Multiduct
200 019 200 067 200 019

200 341 200 341
200 018
200 021
200 023
200 022 200 092 200 022 200 025
Qty Wt.
200 018 Gasket * 0.2

200 019 Screw * 0.2
200 022 Screw * 0.2
200 023 Screw * 0.2
200 025 Gasket * 0.3
200 067 Pin * -
200 092 Screw * 0.3
DBAE577326-
Edition: A
Page: 2(3)
Updated: 13.04.2010
Multiduct
200 014
200 015 200 054
200 056
200 059
200 055
200 060
200 056
200 013 200 057 200 021

200 336 200 023
Qty Wt.
200 013 Multiduct * 72.1

200 014 Adapter * 0.6
200 023 Screw * 0.2
200 054 Pipe * 1.2
200 055 Flange * 0.5
200 056 O-ring * -
200 057 Screw * -
200 059 Blind flange 2 2.3
200 060 Screw 4 -
200 336 Washer * -
DBAE577326-
Edition: A
Page: 3(3)
Updated: 13.04.2010
Multiduct

12V 16V 18V 20V
200 013 Multiduct 12 16 18 20
200 014 Adapter 12 16 18 20
200 015 Sealing ring 12 16 18 20
200 018 Gasket 12 16 18 20
200 019 Screw 36 48 54 60
200 021 Distance piece 48 64 72 80
200 022 Screw 24 32 36 40
200 023 Screw 48 64 72 80
200 025 Gasket 12 16 18 20
200 054 Pipe 10 14 16 18
200 055 Flange 20 28 32 36
200 056 O-ring 22 30 34 38
200 057 Screw 40 56 64 72
200 067 Pin 24 32 36 40
200 092 Screw 12 16 18 20
200 336 Washer 40 56 64 72
200 341 Distance piece 36 48 54 60
DBAE577326-
DBAE577326-
Edition: B
Page: 1(3)
Updated: 13.06.2007
Insulation box
205 022 205 001 205 022 205 026 205 022 205 026
205 025 205 025 205 025
Qty Wt.
205 001 Upper protecting panel 1 50.0

205 022 Cover profile * 3.0
205 025 Lower protecting panel * 30.0
205 026 Upper protecting panel * 39.0
DBAE577326-
Edition: B
Page: 2(3)
Updated: 13.06.2007
Insulation box
205 038 205 017
205 010 205 205
205 016
205 073
Qty Wt.
205 010 Bracket * 0.6

205 016 Screw * 0.1
205 017 Screw * -
205 038 Screw * -
205 073 Washer * -
205 205 Pin * -
DBAE577326-
Edition: B
Page: 3(3)
Updated: 13.06.2007
Insulation box

12V 16V 20V
205 010 Bracket 12 16 20
205 016 Screw 24 32 40
205 017 Screw 6 8 10
205 022 Cover profile 3 4 5
205 025 Lower protecting panel 3 4 5
205 026 Upper protecting panel 2 3 4
205 038 Screw 12 16 20
205 073 Washer 24 32 40
205 205 Pin 6 8 10
DBAE577326-
DBAE577326-
Edition: A
Page: 1(2)
Updated: 14.10.2008
Insulating box, connection part
View A
A
205 225
205 227
205 213 205 062

205 221 205 213 205 052 205 224 205 115
205 223 205 214 205 217 205 225
205 216 205 225 205 221
205 227 205 223
Qty Wt.
205 052 Bracket 1 -

205 062 Washer 6 -
205 115 Screw 18 -
205 213 Washer 4 -
205 214 Bracket 1 -
205 216 Bracket 3 -
205 217 Lower protecting panel 1 -
205 221 Washer 4 -
205 223 Screw 2 -
205 224 Screw 6 -
205 225 Washer 13 -
205 227 Screw 9 -
DBAE577326-
Edition: A
Page: 2(2)
Updated: 14.10.2008
Insulating box, connection part
205 115
205 116 205 121 205 220 205 070
205 116
205 226
205 070
205 049
205 080
205 219
205 218
205 079
205 062 205 198
205 224 205 192
205 081
205 215
205 308
205 308 205 221 205 225 205 481
205 481 205 222 205 228

Qty Wt.
205 049 Upper protecting panel 1 -

205 062 Washer 6 -
205 070 Cover profile 2 -
205 079 Screw 4 -
205 115 Screw 18 -
205 116 Washer 31 -
205 192 Cover profile 1 -
205 198 Pin 4 -
205 221 Washer 4 -
205 222 Screw 2 -
205 224 Screw 6 -
205 225 Washer 13 -
205 226 Screw 14 -
205 228 Screw 3 -
205 308 Screw 2 -
205 481 Washer 2 -
DBAE577326-
Edition: A
Page: 1(2)
Updated: 18.01.2012
Starting air distributor
Section A-A
211 004
211 003
211 009
211 014
211 003
211 012 211 012
A
211 014
211 017
211 016 211 019
211 008 211 020
211 007 211 021
211 006 107 187

211 010
211 001
A
Qty Wt.
107 187 Distributor 1 -

211 001 Plug 10 -
211 003 Housing 1 -
211 006 Bush 10 -
211 007 Slide 10 -
211 008 Spring 10 -
211 009 Screw 2 -
211 010 Plate 1 -
211 012 Cover 1 -
211 014 Screw 3 -
211 016 O-ring 1 -
211 017 O-ring 10 -
211 019 O-ring 10 -
211 020 O-ring 1 -
211 021 O-ring 1 -
DBAE577326-
Edition: A
Page: 2(2)
Updated: 18.01.2012
Starting air distributor
211 019
211 006 211 003
211 009
211 012 211 014

211 017
211 008 211 021
211 009
211 007 211 020
211 016 211 014
211 010 211 001
Qty Wt.
211 001 Plug 10 -

211 003 Housing 1 -
211 006 Bush 10 -
211 007 Slide 10 -
211 008 Spring 10 -
211 009 Screw 2 -
211 010 Plate 1 -
211 012 Cover 1 -
211 014 Screw 3 -
211 016 O-ring 1 -
211 017 O-ring 10 -
211 019 O-ring 10 -
211 020 O-ring 1 -
211 021 O-ring 1 -
DBAE577326-
Edition: E
Page: 1(4)
Updated: 17.06.2013
Shut-down mechanism assembly
213 002
213 001
213 013
213 011
A
213 018
213 015 213 008 A

213 007 213 006 213 034
213 007
213 021 213 033
213 035
213 012
213 010
213 016
213 014
213 020
Qty Wt.
213 001 Shut-down mechanism 1 -

213 002 Stop lever (1) 1 1.1
213 006 Shaft 1 0.5
213 007 Pin 2 -
213 008 Lever 1 0.3
213 010 End cover 1 41.2
213 011 Shaft 1 -
213 012 Connecting lever 1 0.5
213 013 Ball joint 1 -
213 015 Nut 1 -
213 016 Nut 1 -
213 018 Nut 2 -
213 021 Lubricating nipple 1 -
213 033 Plate 1 0.3
213 034 Screw 4 -
DBAE577326-
Edition: E
Page: 2(4)
Updated: 17.06.2013
213 002
213 013
213 008
213 011 213 035
213 018
213 006
213 007
213 015
213 012 213 007
213 016 213 021
213 035
213 020
213 014
Qty Wt.
213 002 Stop lever (1) 1 1.1

213 006 Shaft 1 0.5
213 007 Pin 2 -
213 008 Lever 1 0.3
213 011 Shaft 1 -
213 012 Connecting lever 1 0.5
213 015 Nut 1 -
213 016 Nut 1 -
213 018 Nut 2 -
DBAE577326-
Edition: E
Page: 3(4)
Updated: 17.06.2013
213 002
213 026 213 030 213 031 213 017 213 039
387 026 213 040
213 032 213 027 213 028
213 029 387 020
Qty Wt.
213 002 Stop lever 1 1.1

213 017 Pin 1 -
213 026 Stop lever 1 0.7
213 027 Shaft 1 0.2
213 028 Knob 1 -
213 029 Lever 1 -
213 030 Nut 1 -
213 031 Spring 1 -
213 032 Screw 1 -
213 039 Shaft 1 -
213 040 Pin 1 -
DBAE577326-
Edition: E
Page: 4(4)
Updated: 17.06.2013
213 030
213 026 387 026
213 032
213 031
213 039
213 029
213 028
387 020
213 017 213 027 213 040
Qty Wt.
213 017 Pin 1 -

213 026 Stop lever 1 0.7
213 027 Shaft 1 0.2
213 028 Knob 1 -
213 029 Lever 1 -
213 030 Nut 1 -
213 031 Spring 1 -
213 032 Screw 1 -
213 039 Shaft 1 -
213 040 Pin 1 -
DBAE577326-
Edition: A
Page: 1(1)
Updated: 01.12.2014
Limit switch for stop lever
213 009
213 022
GS 171 GS 177
Qty Wt.
213 009 Screw 4 -

213 022 Bracket 2 0.2
GS171 Limit switch 1 -
GS177 Limit switch 1 0.5
DBAE577326-
DBAE577326-
Edition: A
Page: 1(2)
Updated: 19.05.2015
Main starting valve
217 029
217 012 217 025
217 008
357 017
217 003
Qty Wt.
357 017 Main starting valve 1 -

217 003 Gasket * 1 -
217 008 Spool assembly * 1 -
217 012 Seal * 1 -
217 025 O-ring * 1 -
217 029 O-ring * 2 -
NOTE! (*) Parts available in kit. See page 2.
DBAE577326-
Edition: A
Page: 2(2)
Updated: 19.05.2015
Main starting valve
217 025
217 012
217 029 217 086

217 003
217 008
Qty Wt.
217 086 Overhaul kit 1 -

217 003 Gasket 1 -
217 008 Spool assembly 1 -
217 012 Seal 1 -
217 025 O-ring 1 -
217 029 O-ring 2 -
DBAE577326-
Edition: C
Page: 1(3)
Updated: 05.08.2011
Air block
357 133
218 139
218 140 218 149

357 229 218 148
218 150
357 132
218 165
357 130 A-bank
357 131
B-bank
218 141
218 133
Qty Wt.
218 133 Screw * -

218 139 Bracket 1 25.0
218 140 Bracket * 15.0
218 141 Screw * -
218 148 Bracket * 0.2
218 149 Screw * -
218 150 Bracket 1 24.0
218 165 Nut * -
357 130 Screw * -
357 131 Gasket * -
357 132 Pipe * 4.5
357 133 Pipe 1 8.1
357 229 Pipe 1 7.0
NOTE! (*) See page 3
DBAE577326-
Edition: C
Page: 2(3)
Updated: 05.08.2011
Air block
218 134
218 130
B-bank
218 131
218 136 218 132
218 142 218 135 A-bank
218 147 218 134
Qty Wt.
218 130 Air block 1 156

218 131 Connection piece * -
218 132 Connection piece * 0.1
218 134 Gasket 2 -
218 135 O-ring * -
218 136 O-ring * -
218 142 Distance sleeve * -
218 147 Screw * -
NOTE! (*) See page 3
DBAE577326-
Edition: C
Page: 3(3)
Updated: 05.08.2011
Air block

16V 18V 20V
218 131 Connection piece 8 9 10
218 132 Connection piece 8 9 10
218 133 Screw 10 11 12
218 135 O-ring 16 18 20
218 136 O-ring 16 18 20
218 140 Bracket 1 1 2
218 141 Screw 20 22 24
218 142 Distance sleeve 10 11 12
218 147 Screw 10 11 12
218 148 Bracket 7 8 9
218 149 Screw 7 8 9
218 165 Nut 8 8 12
357 130 Screw 8 8 12
357 131 Gasket 2 2 3
357 132 Pipe 1 1 2
DBAE577326-
DBAE577326-
Edition: A
Page: 1(1)
Updated: 12.03.2008
Booster servomotor
223 027
220 502
220 503 220 505
220 502 220 504
Qty Wt.
223 027 Booster motor 1 -

220 502 O-ring (1) 2 -
220 503 Slide ring (1) 2 -
220 504 O-ring (1) 2 -
220 505 Washer (1) 1 -
NOTE! Parts included in a set or a kit cannot

be ordered separately.
NOTE! Spare part kit 220 396 includes
items marked (1).
DBAE577326-
DBAE577326-
Edition: B
Page: 1(5)
Updated: 11.08.2015
Governor
220 001
220 213 220 395
Qty Wt.
220 001 Governor 1 -

220 213 Oil sight glass 1 -
220 395 Spare part kit (1) 1 0.2
NOTE! (1) Basic overhaul kit.

DBAE577326-
Edition: B
Page: 2(5)
Updated: 11.08.2015
Governor
220 442
220 206
220 445
220 072
220 443
220 068
220 440
220 394
Qty Wt.
220 395 Spare part kit 1 0.2

220 068 Ball bearing (1) 1 -
220 072 Oil seal (1) 1 -
220 206 Gasket (1) 1 -
220 394 Locking plate (1) 1 -
220 440 Gasket (1) 1 -
220 442 Oil seal (1) 1 -
220 443 Gasket (1) 1 -
220 445 O-ring (1) 1 -

items marked (1).
DBAE577326-
Edition: B
Page: 3(5)
Updated: 11.08.2015
Governor
220 456
220 457
220 458
220 458
220 457
220 455
Qty Wt.
220 455 Gasket (1) 1 -

220 456 O-ring (1) 1 -
220 457 Oil seal (1) 2 -
220 458 Bushing (1) 2 -

items marked (1).
DBAE577326-
Edition: B
Page: 4(5)
Updated: 11.08.2015
Governor
220 467
220 465
220 466
220 464
Qty Wt.
220 464 O-ring (1) 4 -

220 465 Washer (1) 2 -
220 466 O-ring (1) 2 -
220 467 Gasket (1) 1 -

items marked (1).
DBAE577326-
Edition: B
Page: 5(5)
Updated: 11.08.2015
Governor
220 583
Qty Wt.
220 583 Cable with connector 1 -
NOTE! * Alternative design
DBAE577326-
DBAE577326-
Edition: D
Page: 1(2)
Updated: 10.11.2009
Booster-motor
387 006
223 108
See page 2
387 006
Qty Wt.
223 108 Screw 1 -

DBAE577326-
Edition: D
Page: 2(2)
Updated: 10.11.2009
Booster-motor
223 106 223 038
223 117
223 105
223 025
223 104 Alternative design
223 026
*223 122
223 038
*223 117
223 028 223 118
223 117
223 029
223 027
223 028 223 117
Qty Wt.
223 025 Pipe 1 -

223 026 Pipe 1 -
223 027 Booster motor 1 -
223 028 Screw 4 -
223 029 Pipe 1 -
223 104 Bracket 1 -
223 106 Screw 1 -
223 122 Adjustable angle union 1 -
NOTE! *) Not used in all installations.
DBAE577326-
Edition: A
Page: 1(4)
Updated: 19.09.2011
Governor drive
223 001 220 001
223 006 223 116
223 112 A 223 136
223 008 223 139
C 223 017
223 003 223 011 C

223 004 223 009
223 003 223 023
223 007
223 002 B 223 016
223 005 223 120
223 103
223 115 A 223 015
B
Qty Wt.
220 001 Governor (1) 1 -

223 001 Governor drive 1 -
223 003 Bearing bush 2 0.1
223 004 Shaft 1 3.1
223 005 O-ring 1 -
223 006 Screw 4 -
223 008 Coupling 1 0.4
223 009 Washer 1 -
223 011 Screw 1 -
223 015 Bracket 1 41.6
223 016 Screw 9 -
223 017 Screw 8 -
223 103 Cylindrical pin 1 0.1
223 112 Gasket 1 -
223 115 Screw 8 -
223 116 Pin 1 -
223 120 Washer 9 -
223 136 Screw 4 -
223 139 Screw 4 -
DBAE577326-
Edition: A
Page: 2(4)
Updated: 19.09.2011
Governor drive
223 006
223 008
223 112
223 011
223 009
223 023
223 007
223 103
223 003 223 015
223 003
223 004 223 005
223 002
223 115
Qty Wt.

223 003 Bearing bush 2 0.1
223 004 Shaft 1 3.1
223 005 O-ring 1 -
223 006 Screw 4 -
223 008 Coupling 1 0.4
223 009 Washer 1 -
223 011 Screw 1 -
223 015 Bracket 1 41.6
223 103 Cylindrical pin 1 0.1
223 112 Gasket 1 -
223 115 Screw 8 -
DBAE577326-
Edition: A
Page: 3(4)
Updated: 19.09.2011
Governor drive
A-A 223 114
223 116 223 016 223 137
223 018 223 120

387 025
223 139
223 133
B-B
223 017
223 019 223 138
223 020 223 022 223 136
223 015 223 021
Qty Wt.
223 015 Bracket 1 41.6

223 016 Screw 9 -
223 017 Screw 8 -
223 018 Pin 2 -
223 019 Bearing 1 1.1
223 020 O-ring 1 -
223 021 O-ring 2 -
223 022 Cover 1 7.5
223 114 Nipple (1) 1 -
223 116 Pin 1 -
223 120 Washer 9 -
223 133 Cover 1 0.2
223 136 Screw 4 -
223 137 Pin 1 -
223 138 Cover 1 1.0
223 139 Screw 4 -
NOTE! (1) Reduction nipple in engine block.
DBAE577326-
Edition: A
Page: 4(4)
Updated: 19.09.2011
Governor drive
223 018 223 019 223 120 223 016 223 137
223 116 223 017
223 139
223 133
223 138
223 020 223 015 223 022 223 136
Qty Wt.
223 015 Bracket 1 41.6

223 016 Screw 9 -
223 017 Screw 8 -
223 018 Pin 2 -
223 019 Bearing 1 1.1
223 020 O-ring 1 -
223 022 Cover 1 7.5
223 116 Pin 1 -
223 120 Washer 9 -
223 133 Cover 1 0.2
223 136 Screw 4 -
223 137 Pin 1 -
223 138 Cover 1 1.0
223 139 Screw 4 -
DBAE577326-
Edition: B
Page: 1(1)
Updated: 20.05.2013
Levers for governor
224 041
224 040 224 065
224 032
224 033
224 064
224 039 224 062
224 038
224 037 224 065
224 034
224 035 224 061
Qty Wt.
224 032 Lever 1 0.7

224 033 Pin 1 -
224 034 Screw 1 -
224 035 Nut 1 -
224 037 Ball joint, right 1 -
224 038 Nut, right-hand 1 -
224 039 Adjustable rod 1 0.7
224 040 Nut, left-hand 1 -
224 041 Ball joint, left 1 -
224 061 Lever 1 0.9
224 062 Shaft 2 -
224 064 Screw 1 -
224 065 Nut 2 -
DBAE577326-
DBAE577326-
Edition: F
Page: 1(3)
Updated: 18.04.2007
Control shaft, B bank
224 060 224 022 224 069 224 004 224 002
224 093
224 003
224 071
A 224 072
224 070
224 060
213 020 A
See 213-
224 053 224 067 224 066 224 054 224 010 224 001 224 005 224 050
224 068 224 031
Qty Wt.

224 001 Torsional spring * -
224 002 Lever * -
224 003 Pin * -
224 004 Follower * -
224 005 Torsional spring * -
224 010 Bearing housing * -
224 022 Nut * -
224 050 Gasket * -
224 054 Pin 1 -
224 060 Screw 2 -
224 066 Lever 1 -
224 067 Screw 1 -
224 068 Nut 1 -
224 069 Screw bush 1 -
224 071 Limiter 1 -
224 072 Control shaft 1 -
224 093 Limiter 1 -
NOTE! * See page 3.
DBAE577326-
Edition: F
Page: 2(3)
Updated: 18.04.2007
SECTION A - A
224 019 224 018 224 055 224 049 224 048 224 020
224 051
224 021
224 022
Qty Wt.
224 018 Shaft for lever * -

224 019 Lever * -
224 020 Screw * -
224 021 Sleeve for injection * -
pump
224 022 Nut * -
224 048 Nut * -
224 049 Screw * -
224 051 Pin * -
224 055 Screw * -
NOTE! * See page 3.
DBAE577326-
Edition: F
Page: 3(3)
Updated: 18.04.2007
Pieces
Part No 12V32 16V32 18V32 20V32
224 001 6 8 9 10
224 002 6 8 9 10
224 003 18 24 27 30
224 004 6 8 9 10
224 005 6 8 9 10
224 010 7 9 10 11
224 018 6 8 9 10
224 019 6 8 9 10
224 020 6 8 9 10
224 021 12 16 18 20
224 022 8 10 11 12
224 048 6 8 9 10
224 049 6 8 9 10
224 050 14 18 20 22
224 051 6 8 9 10
224 055 14 18 20 22
DBAE577326-
DBAE577326-
Edition: D
Page: 1(3)
Updated: 07.10.2005
Bearing support for link levers
224 078 224 081 224 080 224 077

224 083
224 079
224 075 224 075
224 073 224 074
Qty Wt.
224 073 Bearing bracket 1 -

224 074 Screw 4 -
224 075 Connecting lever 2 -
224 078 Nut 4 -
224 079 Pin 2 -
224 080 Washer 1 -
224 081 Nut 1 -
DBAE577326-
Edition: D
Page: 2(3)
Updated: 07.10.2005
224 075
224 085 224 086
224 084 224 091 224 087 224 090
224 088 224 088 224 089
Qty Wt.

224 085 Nut 1 -
224 086 Plug 1 -
224 087 Rod 1 -
224 088 Washer 2 -
224 090 Nut 1 -
224 091 Plug 1 -
DBAE577326-
Edition: D
Page: 3(3)
Updated: 07.10.2005
224 081
224 078 224 080
224 079 224 083
224 077
224 083 224 073
224 078
224 074
224 075
224 085 224 091 224 087 224 086 224 090
224 084 224 088 224 088 224 089
Qty Wt.
224 073 Bearing bracket 1 -

224 074 Screw 4 -
224 085 Nut 1 -
224 086 Plug 1 -
224 087 Rod 1 -
224 088 Washer 2 -
224 090 Nut 1 -
224 091 Plug 1 -
224 078 Nut 4 -
224 079 Pin 2 -
224 080 Washer 1 -
224 081 Nut 1 -
DBAE577326-
DBAE577326-
Edition: B
Page: 1(3)
Updated: 09.11.2016
Control shaft, A bank
224 003 224 004 224 005 224 009 224 022
224 059 224 069 224 022
224 010 224 060 224 056
224 031
A 224 012
224 053
224 008 A 224 052

224 067 224 054 224 054
224 001 224 002 224 050 224 068 224 066 224 058
Qty Wt. Qty Wt.

224 001 Torsional spring * 0.3

224 002 Lever * 0.4 NOTE! * See page 3.
224 003 Pin * -
224 004 Follower * 0.2
224 005 Torsional spring * 0.1
224 008 Control shaft 1 32.1
224 009 Lever 1 0.4
224 010 Bearing housing * 1.8
224 012 Lever 1 1.6
224 022 Nut * -
224 050 Gasket * -
224 052 Follower 1 0.2
224 054 Pin 2 -
224 056 Shaft 1 -
224 058 Screw 1 -
224 059 Pin 1 -
224 060 Screw 1 -
224 066 Lever 1 0.7
224 067 Screw 1 0.1
224 068 Nut 1 -
224 069 Screw bush 1 -
DBAE577326-
Edition: B
Page: 2(3)
Updated: 09.11.2016
A-A
224 019 224 055 224 049 224 048 224 020
224 018
224 051
224 021
224 022
Qty Wt.
224 018 Shaft for lever * -

224 019 Lever * 0.1
224 020 Screw * -
224 021 Sleeve for injection * -
pump
224 022 Nut * -
224 048 Nut * -
224 049 Screw * 0.1
224 051 Pin * -
224 055 Screw * -
NOTE! * See page 3.
DBAE577326-
Edition: B
Page: 3(3)
Updated: 09.11.2016

12V 16V 18V 20V
224 001 Torsional spring 6 8 9 10
224 002 Lever 6 8 9 10
224 003 Pin 18 24 27 30
224 004 Follower 6 8 9 10
224 005 Torsional spring 6 8 9 10
224 010 Bearing housing 7 9 10 11
224 018 Shaft for lever 6 8 9 10
224 019 Lever 6 8 9 10
224 020 Screw 6 8 9 10
224 021 Sleeve for injection pump 12 16 18 20
224 022 Nut 10 12 13 14
224 048 Nut 6 8 9 10
224 049 Screw 6 8 9 10
224 050 Gasket 14 18 20 22
224 051 Pin 6 8 9 10
224 055 Screw 14 18 20 22
DBAE577326-
DBAE577326-
Edition: C
Page: 1(1)
Updated: 02.09.1998
Overspeed trip device
228 005
228 010
See 228-
228 008
228 009
Qty Wt.
228 005 Screw 2 -

228 008 Pipe 1 -
228 010 Overspeed trip device 1 -
DBAE577326-
DBAE577326-
Edition: E
Page: 1(3)
Updated: 21.04.2008
357 058
357 065
A
357 076
228 005
228 010
See 228-
228 103
228 111
228 112 357 193
357 189
357 188
Qty Wt.
228 005 Screw * -

228 010 Overspeed trip device * 0.7
228 103 Pipe * -
228 112 Screw 2 -
357 058 Screw 8 -
357 065 Pipe clamp 4 0.2
357 076 Pipe 1 0.6
357 188 Pipe union * 0.1
357 189 Pipe 1 -
357 193 Pipe * 0.2
NOTE! * See page 3.
DBAE577326-
Edition: E
Page: 2(3)
Updated: 21.04.2008
View A
357 071
357 058
357 065
357 075
357 023
357 013
357 069
357 074
357 068
Qty Wt.
357 013 Pipe 1 -

357 058 Screw 8 -
357 065 Pipe clamp 4 0.2
357 068 Pipe union (1) 1 -
357 069 Pipe union 1 0.1
357 074 Pipe (1) 1 -
357 075 Pipe 1 0.3
DBAE577326-
Edition: E
Page: 3(3)
Updated: 21.04.2008

Pieces
Part No 12V32 16V32 18V32 20V32
228 005 12 16 18 20
228 103 6 8 9 10
228 010 6 8 9 10
357 188 6 8 9 10
357 193 5 7 8 9
Qty Wt.
228 005 Screw 2 -

228 010 Overspeed trip device 9 0.7
228 103 Pipe 9 -
357 188 Pipe union 9 0.1
357 193 Pipe 8 0.2
DBAE577326-
DBAE577326-
Edition: B
Page: 1(2)
Updated: 08.08.2017
228 010
228 004 228 014 228 005
A
228 012 228 013 228 002 228 015
387 017 387 029
Qty Wt.
228 010 Overspeed trip device 1 -

228 002 Piston 1 -
228 005 Screw 2 -
228 012 Screw 1 -
228 013 Washer 1 -
228 014 Slide o-ring 1 -
228 015 Cylinder 1 0.5
DBAE577326-
Edition: B
Page: 2(2)
Updated: 08.08.2017
228 014
228 005
228 013 228 012 228 002 228 015

387 017 387 029
Qty Wt.
228 002 Piston 1 -

228 005 Screw 2 -
228 012 Screw 1 -
228 013 Washer 1 -
228 014 Slide o-ring 1 -
228 015 Cylinder 1 0.5
DBAE577326-
Edition: G
Page: 1(4)
Updated: 10.01.2012
Air bottle
228 034 228 016 A 228 023
228 037 228 022
228 102 228 030
228 029 A 228 031

B 228 024
228 027
Alternative
228 028 228 029 228 026 A
228 025 A
228 056
228 032
228 080
228 079
228 081 228 040
228 106
228 107
228 110
Qty Wt.
228 040 Air bottle assembly 1 -

228 016 Air bottle 1 -
228 022 Flange 1 -
228 023 Screw 4 -
228 024 O-ring 1 -
228 025 Sleeve 1 -
228 026 Screw 3 -
228 027 O-ring 1 -
228 028 Pipe 1 -
228 029 O-ring 2 -
228 030 Plug 1 -
228 032 Screw 3 -
228 034 Screw 1 -
228 037 Screw 1 -
228 056 O-ring 1 -
228 079 Flange 1 -
228 080 O-ring 1 -
228 081 Screw 4 -
228 102 Screw 4 -
228 106 Lead-through piece 2 -
228 107 Screw 2 -
228 110 O-ring 2 -
DBAE577326-
Edition: G
Page: 2(4)
Updated: 10.01.2012
Air bottle
228 037 228 016 228 024 228 022 228 031 228 030 228 023
228 034 228 026

228 027
228 102
228 056 228 028 228 029 228 025
228 032
228 080
228 079
228 106
228 081 228 107
228 110
Qty Wt.

228 022 Flange 1 -
228 023 Screw 4 -
228 024 O-ring 1 -
228 025 Sleeve 1 -
228 026 Screw 3 -
228 027 O-ring 1 -
228 028 Pipe 1 -
228 029 O-ring 2 -
228 030 Plug 1 -
228 032 Screw 3 -
228 034 Screw 1 -
228 037 Screw 1 -
228 056 O-ring 1 -
228 079 Flange 1 -
228 080 O-ring 1 -
228 081 Screw 4 -
228 102 Screw 4 -
228 107 Screw 2 -
228 110 O-ring 2 -
DBAE577326-
Edition: G
Page: 3(4)
Updated: 10.01.2012
Air bottle
Section A-A View B
228 061
228 108
387 006
228 105 387 025
228 049
228 050
Qty Wt.

228 050 Plug 1 -
228 061 Plug 1 -
228 105 Sealing ring * 2 -
228 108 Plug * 2 -
NOTE! *) Amount depends on installation.
DBAE577326-
Edition: G
Page: 4(4)
Updated: 10.01.2012
Air bottle
228 113
228 119
228 114
228 120
228 105
228 056
228 108
228 123
228 124
Qty Wt.
228 056 O-ring 1 -

228 108 Plug * 2 -
228 113 Support 1 -
228 114 Screw 2 -
228 120 Screw * 1 -
228 123 Plug * 1 -
DBAE577326-
Edition: A
Page: 1(1)
Updated: 27.03.2009
Load limiter assembly, hot box
228 053
View A
228 054
228 044
228 082
228 042
228 083
228 043
228 041
Qty Wt.
228 041 Bracket 1 -

228 042 Screw 1 -
228 043 Nut 1 -
228 044 Screw 4 -
228 053 V-ring 2 -
228 082 Screw 1 -
228 083 Nut 1 -
DBAE577326-
DBAE577326-
Edition: B
Page: 1(4)
Updated: 10.01.2012
Air bottle, B-Bank
228 084 228 056 228 029 228 028

228 034
228 026 228 104
228 025
A
228 052
228 029
228 027
228 061
B
387 006
228 032
228 077
228 076
228 078
Qty Wt.
228 052 Air bottle for overspeed 1 -

trip device
228 025 Sleeve 1 -
228 026 Screw 3 -
228 027 O-ring 1 -
228 028 Pipe 1 -
228 029 O-ring 2 -
228 032 Screw 4 -
228 034 Screw 1 -
228 056 O-ring 1 -
228 061 Plug 1 -
228 076 Flange 1 -
228 077 O-ring 1 -
228 078 Screw 4 -
228 104 Screw 4 -
DBAE577326-
Edition: B
Page: 2(4)
Updated: 10.01.2012
Air bottle, B-Bank
228 084
228 034
228 026 228 025 228 028 228 104
228 027 228 077
228 029 228 056

228 076
228 078
228 032
Qty Wt.
228 025 Sleeve 1 -

228 026 Screw 3 -
228 027 O-ring 1 -
228 028 Pipe 1 -
228 029 O-ring 2 -
228 032 Screw 4 -
228 034 Screw 1 -
228 056 O-ring 1 -
228 076 Flange 1 -
228 077 O-ring 1 -
228 078 Screw 4 -
228 104 Screw 4 -
DBAE577326-
Edition: B
Page: 3(4)
Updated: 10.01.2012
Air bottle, B-Bank
228 074
228 075
228 100
387 006
387 025
Qty Wt.
228 074 Plug 1 -

228 100 Screw 2 -
DBAE577326-
Edition: B
Page: 4(4)
Updated: 10.01.2012
Air bottle, B-Bank
228 034
228 032
228 104
228 074
228 075
228 123
228 124
Qty Wt.
228 032 Screw 4 -

228 034 Screw 1 -
228 074 Plug 1 -
228 104 Screw 4 -
228 123 Plug 1 -
DBAE577326-
Edition: C
Page: 1(1)
Updated: 14.09.2007
Cover for fuel pipes
View A
350 261
350 263
350 603
350 262
350 917
350 245
350 244
350 243
Qty Wt.
350 243 Cover 1 5.1

350 244 Nut 6 -
350 245 Screw 1 -
350 261 Washer 2 -
350 262 Cover 1 0.7
350 263 Screw 2 -
350 603 Screw 1 -
350 917 Washer 1 -
DBAE577326-
DBAE577326-
Edition: B
Page: 1(2)
Updated: 29.05.2014
Pressure valve
350 727
350 729 350 728
350 732
350 723
350 731
350 730
350 724
350 733
350 048
350 725 350 249

350 726
Qty Wt.
350 048 Control valve (1) 1 -

350 249 Pressure valve (1) 1 -
350 723 Plug 1 -
350 724 Spindle 1 -
350 725 Piston 1 -
350 726 Spring 1 -
350 727 Cap 1 -
350 728 Screw 1 -
350 729 Nut 1 -
350 732 Screw 1 -
350 730 O-ring (2) 1 -
350 731 Seal (2) 1 -
NOTE! (1) The pressure valve can be code

350 048 or 350 249, see section
350-xx.
NOTE! (2) Note! Sealings available as
sealing set only.
DBAE577326-
Edition: B
Page: 2(2)
Updated: 29.05.2014
Pressure valve
350 724
350 727
350 729
350 728 350 726
350 732
350 731
350 723 350 725
350 730
Qty Wt.
350 723 Plug 1 -

350 724 Spindle 1 -
350 725 Piston 1 -
350 726 Spring 1 -
350 727 Cap 1 -
350 728 Screw 1 -
350 729 Nut 1 -
350 730 O-ring 1 -
350 731 Seal 1 -
350 732 Screw 1 -
NOTE! (1) The pressure valve can be code

350 048 or 350 249, see section
350-xx.
NOTE! (2) Note! Sealings available as
sealing set only.
DBAE577326-
Edition: F
Page: 1(1)
Updated: 03.02.2016
Bracket
350 125
350 123
387 056
350 133
350 232
350 131
350 129
Qty Wt.
350 232 Bracket * 1 -

350 123 Nut 4 -
350 125 O-ring 2 -
350 129 Sleeve 2 0.4
350 133 Screw 1 -
NOTE! *) See fuel system.
DBAE577326-
DBAE577326-
Edition: C
Page: 1(1)
Updated: 05.02.2010
Fuel pipes in free end
350 220
350 222
350 222
350 1199 350 226
350 225
350 225 350 228
350 227
350 224 350 745
350 229 350 218
350 216
350 216
350 221 350 217
350 219
350 225
350 217
Qty Wt.
350 216 Pipe 2 -

350 217 Pipe 2 -
350 218 Pipe 1 -
350 219 Pipe 1 -
350 220 O-ring 8 -
350 221 Screw 16 -
350 222 Screw 18 -
350 224 Screw 2 -
350 225 Washer 50 -
350 226 Nut 4 -
350 745 Screw 4 -
350 1199 Nut 16 -
DBAE577326-
DBAE577326-
Edition: C
Page: 1(1)
Updated: 02.03.2009
Fuel pipes in free end
350 256
350 257
350 258
350 254 350 259
350 260
350 252
350 249 350 253
See 350- 350 255
350 255 350 260
350 017 350 016
350 052 350 257
350 053 350 258
350 055 350 259
350 767 350 260
Qty Wt.
350 016 Pipe 1 4.3

350 017 Pipe 1 4.0
350 052 Screw 4 -
350 053 Pipe clamp 1 7.3
350 055 Screw 2 -
350 249 Pressure valve 1 5.4
350 252 O-ring 2 -
350 253 Screw 2 -
350 254 Support 1 3.0
350 255 Screw 6 -
350 256 Pipe 1 2.8
350 257 O-ring 2 -
350 258 Screw 2 -
350 259 Screw 6 -
350 260 Washer * 16 -
350 767 Nut 6 -
DBAE577326-
DBAE577326-
Edition: A
Page: 1(2)
Updated: 16.06.2006
Fuel oil pipes in free end
350 934
350 949
350 947
350 145
350 773 350 950 A
350 771
350 755
350 952
350 752
350 768
350 951
350 952
350 934
350 947
350 934
350 947
Qty Wt.

350 752 Bracket 1 -
350 768 Pipe 1 -
350 934 Nut 24 -
350 947 Screw 16 -
350 949 Pipe 1 -
350 950 Pipe 1 -
350 952 Screw 8 -
DBAE577326-
Edition: A
Page: 2(2)
Updated: 16.06.2006
Fuel oil pipes in free end
View A
350 773
350 647
350 648
350 760
350 649
350 987
350 749
350 748
350 935
350 760
350 757
350 933 350 751
350 933
350 934 350 649
350 754 350 934
350 988
604 728
350 989
604 729
Qty Wt.
350 647 Screw 8 -

350 648 Nut 8 -
350 649 O-ring 6 -
350 748 Pipe 1 -
350 749 Pipe 1 -
350 751 Pipe 2 -
350 757 Screw 6 -
350 760 Screw 20 -
350 933 Washer 12 -
350 934 Nut 24 -
350 935 Plate 6 -
350 987 Spring washer 16 -
350 988 Screw 6 -
604 728 Pipe 1 -
604 729 Pipe 1 -
DBAE577326-
Edition: B
Page: 1(3)
Updated: 04.02.2016
Fuel pipes
C
B A
350 850
350 859 350 851
C
350 845
350 846 350 429
350 849
350 851
350 859
350 860
D
D
Qty Wt.
350 429 Plug 4 0.8

350 846 Screw 4 0.2
350 851 Screw 4 -
350 859 Screw 8 -
DBAE577326-
Edition: B
Page: 2(3)
Updated: 04.02.2016
Fuel pipes
D-D
350 964
350 848
350 848
350 852
387 056
B
E
350 845
350 849
350 850
350 851
350 851
350 859
350 860
Qty Wt.

350 848 Sleeve 6 0.4
350 851 Screw 4 -
350 852 O-ring 8 -
350 859 Screw 8 -
350 964 O-ring 4 -
DBAE577326-
Edition: B
Page: 3(3)
Updated: 04.02.2016
Fuel pipes
350 859 E
350 846 350 845
350 429
350 944
350 945
F
F-F
350 964
350 848 350 847
350 852 350 852
387 056 387 056

350 848 350 847
Qty Wt.
350 429 Plug 4 0.8

350 944 Plug 1 0.1
350 846 Screw 4 0.2
350 847 Sleeve 2 0.4
350 848 Sleeve 6 0.4
350 852 O-ring 8 -
350 859 Screw 8 -
350 964 O-ring 4 -
DBAE577326-
DBAE577326-
Edition: A
Page: 1(4)
Updated: 05.07.2010
Covers
A B C
A B C
DBAE577326-
Edition: A
Page: 2(4)
Updated: 05.07.2010
Covers
Section A - A
View D
350 1291 350 1287

350 1288
350 1290
350 1287
350 1292
350 1289
350 1287 350 1287
350 1288 350 1288
Qty Wt.
350 1287 Washer 48 -

350 1288 Screw 33 -
350 1289 Screw 12 -
350 1290 Cover 1 4.8
350 1291 Cover 1 1.2
350 1292 Cover 1 0.2
DBAE577326-
Edition: A
Page: 3(4)
Updated: 05.07.2010
Covers
Section B - B
View E 350 1295

350 1294 350 1296 350 1287
350 1288
350 1287
350 1288
350 1293 350 1287
350 1298 350 1287 350 1288
350 1299 350 1297
Qty Wt.
350 1287 Washer 48 -

350 1288 Screw 33 -
350 1293 Cover 1 0.3
350 1294 Cover 1 0.4
350 1295 Cover 1 1.2
350 1296 Cover 1 0.6
350 1297 Screw 3 -
350 1298 Washer 2 -
350 1299 Screw 2 -
DBAE577326-
Edition: A
Page: 4(4)
Updated: 05.07.2010
Covers
Section C - C
View F 350 1285

350 1286
350 1287
F 350 1288
350 1284
350 1287
350 1288
350 1287
350 1289
Qty Wt.
350 1284 Cover 1 3.8

350 1285 Cover 1 1.6
350 1286 Cover 1 1.3
350 1287 Washer 48 -
350 1288 Screw 33 -
350 1289 Screw 12 -
DBAE577326-
Edition: C
Page: 1(1)
Updated: 03.06.2015
Fuel pipes
350 926
350 129
350 132
350 133
350 134 350 134

387 056 387 056
Qty Wt.
350 926 Pipe *) 1 -

350 129 Sleeve 2 0.4
350 133 Screw 1 -
350 134 O-ring 4 -
DBAE577326-
DBAE577326-
Edition: B
Page: 1(2)
Updated: 03.06.2015
Fuel pipe
350 126
350 129
350 132
350 133
350 133
350 187
Qty Wt.
350 126 Pipe 1 -

350 129 Sleeve 4 0.4
350 133 Screw 2 -
DBAE577326-
Edition: B
Page: 2(2)
Updated: 03.06.2015
Fuel pipe
A Section A-A
350 134 350 134
387 056 387 056
A
350 134 350 134
387 056 387 056
Qty Wt.
350 134 O-ring 4 -

DBAE577326-
Edition: C
Page: 1(2)
Updated: 13.01.2017
Fuel system
165 001
350 122 161 001 350 125

387 056
Qty Wt.
161 001 Lifter, compl. (1) 1 -

165 001 Injection pump (2) 1 -
350 122 Nut 3 -
350 125 O-ring 4 -

DBAE577326-
Edition: C
Page: 2(2)
Updated: 13.01.2017
Fuel system
161 020 100 105

350 124
350 122
Qty Wt.
100 105 Screw 4 0.4

161 020 Screw 2 -
350 122 Nut 3 -
350 124 Nut 4 0.1
DBAE577326-
Edition: A
Page: 1(2)
Updated: 09.11.2016
Bracket for fuel system
350 129 350 123
A
350 132 350 127
350 133
350 129
Qty Wt.
350 127 Bracket *) 1 -

350 123 Nut 4 -
350 129 Sleeve 2 0.4
350 133 Screw 1 -
DBAE577326-
Edition: A
Page: 2(2)
Updated: 09.11.2016
Bracket for fuel system
A 350 134 387 026 B-B 350 137

B 387 056 350 138
B 350 134 387 026

387 056
Qty Wt.
350 134 O-ring 2 -

350 137 Plug 2 -
DBAE577326-
Edition: D
Page: 1(2)
Updated: 28.03.2012
Oil nozzle for intermediate gears
352 005
352 007
352 156
352 004 352 223 352 005

352 005 352 224 352 006
352 007 352 226 352 007
352 224
352 491
352 228 352 876
352 004
352 005
352 005
352 007
352 007
352 156
352 223
352 223
352 224
352 224
352 225
352 225
352 227
Qty Wt.
352 004 Oil nozzle 2 0.6

352 005 O-ring 10 -
352 006 Oil nozzle 1 0.6
352 007 Screw 5 -
352 156 Oil nozzle 2 0.7
352 223 Reduction piece 3 0.1
352 227 Pipe 2 -
352 228 Screw 1 -
352 491 Screw 2 -
NOTE! Page 1 is for clockwise rotating

engine. For counterclockwise
rotating engine see page 2.
DBAE577326-
Edition: D
Page: 2(2)
Updated: 28.03.2012
Oil nozzle for intermediate gears
352 005
352 007 352 004
352 156 352 005
352 005 352 223 352 007
352 006 352 224 352 224
352 007 352 226 352 228
352 491
352 876
352 005
352 004
352 007
352 005
352 156
352 007
352 223
352 223
352 224
352 224
352 225
352 225
352 227
Qty Wt.
352 004 Oil nozzle 2 0.6

352 005 O-ring 10 -
352 006 Oil nozzle 1 0.6
352 007 Screw 5 -
352 156 Oil nozzle 2 0.7
352 223 Reduction piece 3 0.1
352 227 Pipe 2 -
352 228 Screw 1 -
352 491 Screw 2 -
NOTE! Page 2 is for counterclockwise

rotating engine. For clockwise
rotating engine see page 1.
DBAE577326-
Edition: B
Page: 1(2)
Updated: 04.11.2005
Lube oil pipes
352 338
352 339
352 252
352 253
352 514
352 338
352 513
352 339
352 338 352 399
352 400
352 339
352 186 352 401
352 185 A
352 196
Qty Wt.
352 185 Pipe 1 -

352 186 Pipe 1 -
352 252 Fastening plate 2 -
352 253 Screw 6 -
352 339 Plug 4 -
352 400 Screw 2 -
352 401 Screw 2 -
DBAE577326-
Edition: B
Page: 2(2)
Updated: 04.11.2005
Lube oil pipes
Section A-A
352 192
352 184 352 193
352 183
352 403 352 402

352 190
352 188
352 193
352 338
352 339
Qty Wt.
352 183 Pipe 2 -

352 184 Pipe 2 -
352 190 Screw 8 -
352 192 O-ring 2 -
352 193 O-ring 4 -
352 339 Plug 4 -
352 402 O-ring 2 -
352 403 O-ring 2 -
DBAE577326-
Edition: B
Page: 1(1)
Updated: 10.02.2014
Oil pipe
352 608
352 607
352 603
352 606 352 604
352 605
Qty Wt.
352 603 Pipe 1 0.1

352 604 Screw 3 -
352 605 Clamp 6 0.2
352 607 Reduction union 1 -
352 608 Pipe union 1 0.2
DBAE577326-
DBAE577326-
Edition: C
Page: 1(1)
Updated: 29.05.2014
Pressure pipe from prelube pump
352 629
352 613
387 003
352 612 352 615 352 613
387 003
Qty Wt.
352 612 Pipe 1 33.2

352 613 Screw 8 0.1
352 615 O-ring 1 -
352 629 O-ring 1 -
DBAE577326-
DBAE577326-
Edition: K
Page: 1(2)
Updated: 07.09.2011
Oil suction pipe
352 633
352 217 352 631

X
352 137
352 213
352 135
352 215
352 750
352 749
352 218
352 130
352 131
352 214
352 132 352 216

352 741 352 750
Qty Wt.
352 130 O-ring 2 -

352 131 Pipe 1 -
352 132 Screw 12 -
352 135 Screw 12 -
352 137 O-ring 1 -
352 213 Screw 8 -
352 214 Screw 12 -
352 215 Nut 8 -
352 216 Nut 12 -
352 217 Pipe 1 -
352 218 Pipe 1 -
352 631 O-ring 1 -
352 633 Valve 1 -
352 741 Washer 12 -
352 749 Washer 16 -
352 750 Washer 36 -
DBAE577326-
Edition: K
Page: 2(2)
Updated: 07.09.2011
Oil suction pipe
Detail X
352 638
352 635
387 017
352 637
352 641 352 635
387 017
352 634
387 017
352 712
352 637
352 748
387 017
Qty Wt.
352 634 Screw 4 -

352 635 Screw 8 -
352 637 O-ring 2 -
352 638 O-ring 1 -
352 641 Pipe 1 -
352 712 O-ring 1 -
352 748 Screw 4 -
DBAE577326-
Edition: B
Page: 1(1)
Updated: 15.12.2008
Lube oil connection
352 620 352 618
352 619 387 020
387 020 352 617
352 616
352 621
352 618 352 620 352 621 352 618

387 020
Qty Wt.

352 617 O-ring 1 -
352 618 Screw 24 -
352 619 Screw 8 -
352 620 O-ring 3 -
352 621 Flange 2 7.3
DBAE577326-
DBAE577326-
Edition: C
Page: 1(2)
Updated: 13.06.2012
Lubricating oil pipes in flywheel end
352 471 352 285
352 472
352 483
352 466 352 289
352 484
352 468 352 856 352 026
352 469 352 857

352 470 352 858
352 479
352 023
352 471 352 480
352 467 352 280
352 278
352 482
See page 2
352 476 352 152 352 481
352 477 352 025 352 020 352 482
352 478 352 485
Qty Wt. Qty Wt.

352 020 O-ring 1 - 352 481 Nut 8 -

352 023 O-ring 1 - 352 482 Washer 14 -
352 025 Screw 4 - 352 483 Plug 1 -
352 026 Pipe 1 17.9 352 484 Sealing ring 1 -
352 856 Screw 4 - 352 485 Washer 4 -
352 857 Washer 4 -
352 858 O-ring 1 -
352 152 Pipe 1 26.7
352 278 Screw 4 -
352 280 Bracket 1 4.7
352 285 O-ring 1 -
352 289 Screw 4 -
352 466 Bend 1 41.4
352 467 Pipe 1 15.3
352 468 Screw 4 -
352 469 Nut 4 -
352 470 Washer 4 -
352 471 O-ring 3 -
352 472 Screw 8 -
352 476 O-ring 1 -
352 477 Support ring 2 -
352 478 Guide ring 1 -
352 479 Screw 5 0.1
352 480 Screw 3 0.2
DBAE577326-
Edition: C
Page: 2(2)
Updated: 13.06.2012
Lubricating oil pipes in flywheel end
352 475
352 482
352 473
352 474
352 864
Qty Wt.
352 473 Pipe clamp 1 5.0

352 474 Screw 3 0.3
352 475 Screw 4 0.1
352 482 Washer 14 -
352 864 Washer 3 -
DBAE577326-
Edition: F
Page: 1(1)
Updated: 12.12.2008
LT-water pipes in flywheel end
354 088
354 055
354 051
354 087
354 086
354 085
354 090 354 084 354 106
354 091 354 093 354 107
354 092 354 088 354 080
354 079
354 081
354 083
354 082
Qty Wt.
354 051 Pipe 1 19.8

354 055 Screw 12 -
354 079 Bend 1 16.0
354 080 O-ring 1 -
354 081 Plug 1 -
354 083 Screw 4 -
354 084 Screw 7 -
354 086 Screw 3 -
354 087 Pipe 1 23.6
354 088 O-ring 3 -
354 091 O-ring 2 -
354 092 Guide ring 2 0.2
354 106 Screw 1 -
354 107 Nut 1 -
DBAE577326-
DBAE577326-
Edition: B
Page: 1(1)
Updated: 25.06.2009
Air vent system, LT water
355 336
355 337
355 362
355 339
355 424
355 340
Qty Wt.

355 339 Pipe 1 -
355 362 Screw 1 -
DBAE577326-
DBAE577326-
Edition: B
Page: 1(1)
Updated: 25.06.2009
Air vent system, HT water
355 366
355 578
355 579
355 364
355 575
355 576
355 577
355 365
355 533
Qty Wt.
355 364 Pipe 1 -

355 576 Screw 2 -
355 577 Washer 2 -
355 579 Screw 1 -
DBAE577326-
DBAE577326-
Edition: C
Page: 1(4)
Updated: 18.03.2011
Cooling water pipes
C C
387 025
355 443
355 446
355 447
355 444
355 445
Qty Wt.
355 443 Bend 1 -

355 445 Plug 8 -
355 446 Screw 2 -
355 447 Screw 2 -
DBAE577326-
Edition: C
Page: 2(4)
Updated: 18.03.2011
Cooling water pipes
View A
355 439
B
355 378
355 697
355 698
355 444
355 445
355 453
355 698
Qty Wt.
355 378 O-ring 3 -

355 439 Pipe 1 -
355 445 Plug 8 -
355 453 Washer 8 -
355 697 Flange 1 -
355 698 Screw 6 -
DBAE577326-
Edition: C
Page: 3(4)
Updated: 18.03.2011
Cooling water pipes
355 444
Detail B
355 445 355 440
355 442
355 389
355 453 355 377

355 698 355 378
355 387
355 453
355 441
Qty Wt.
355 377 Screw 4 -

355 378 O-ring 3 -
355 387 Flange 2 -
355 389 Screw 5 -
355 440 Bend 1 -
355 441 Pipe 1 -
355 442 O-ring 4 -
355 445 Plug 8 -
355 453 Washer 8 -
355 698 Screw 8 -
DBAE577326-
Edition: C
Page: 4(4)
Updated: 18.03.2011
Cooling water pipes
Section C - C
355 442 355 378 355 442
355 378 355 442
Qty Wt.
355 378 O-ring 3 -

355 442 O-ring 4 -
DBAE577326-
Edition: A
Page: 1(2)
Updated: 06.10.2009
Air vent system from multiducts
View A
A B
355 026 355 035 355 037
A-BANK B-BANK
Free end
View B
355 037 355 035 355 026
Free end
Qty Wt.
355 026 Pipe * -

355 035 Pipe union * -
DBAE577326-
Edition: A
Page: 2(2)
Updated: 06.10.2009
Air vent system from multiducts

12V 16V 18V 20V
355 026 Pipe 10 14 16 18
355 035 Pipe union 10 14 16 18
DBAE577326-
Edition: A
Page: 1(5)
Updated: 12.10.2009
Air vent system from oil module
20V
355 247
355 245 See 355- 355 736
355 035 355 717 355 400 355 407
355 736 355 406
355 341
Qty Wt.
355 245 Pipe 1 -

355 341 Pipe 1 -
355 400 Pipe 1 -
355 717 Pipe * -
NOTE! *) See page 5
DBAE577326-
Edition: A
Page: 2(5)
Updated: 12.10.2009
12V
355 247
355 245 See 355- 355 400 355 407
355 736 355 736 355 406
355 341
Qty Wt.
355 245 Pipe 1 -

355 341 Pipe 1 -
355 400 Pipe 1 -
NOTE! *) See page 5
DBAE577326-
Edition: A
Page: 3(5)
Updated: 12.10.2009
16V & 18V

355 247
355 400
355 245 See 355- 355 407
355 736 355 406

355 736
355 341
Qty Wt.
355 245 Pipe 1 -

355 341 Pipe 1 -
355 400 Pipe 1 -
NOTE! *) See page 5
DBAE577326-
Edition: A
Page: 4(5)
Updated: 12.10.2009
View A
355 401 355 398 355 408
355 711
355 714
355 403 355 399
355 410
355 736
355 403
355 410
355 713
355 403 355 711
355 712 355 715
355 716
Qty Wt.
355 398 Pipe 1 -

355 399 Pipe 1 -
355 401 Support 1 -
355 408 Ball valve 1 -
355 410 Screw 2 -
355 711 Screw 4 -
355 712 Screw 2 -
355 713 Nut 1 -
355 714 Washer 2 -
355 715 Support 1 -
NOTE! *) See page 5
DBAE577326-
Edition: A
Page: 5(5)
Updated: 12.10.2009

12V 16V 18V 20V
355 717 Pipe - - - 1
355 736 Pipe union 3 3 3 4
DBAE577326-
DBAE577326-
Edition: A
Page: 1(3)
Updated: 06.06.2012
Air vent system connection part
355 642 355 703 355 702

355 686 355 704 355 704
355 705 355 705
355 244 355 249 355 707
355 249 355 252
355 252 355 708
355 704
355 706
355 642
A 355 686 355 694

See 355-
See 355-
Qty Wt.
355 244 Pipe 1 0.3

355 249 Pipe clamp 34 -
355 252 Screw 33 -
355 642 Pipe 2 0.8
355 694 Pipe 2 1.1
355 702 Support 5 -
355 703 Support 26 0.2
355 704 Washer 96 -
355 705 Screw 62 -
355 706 Nut 26 -
355 707 Ball valve 2 0.1
355 708 Pipe 1 0.2
DBAE577326-
Edition: A
Page: 2(3)
Updated: 06.06.2012
355 642
355 252 355 252
355 547 355 547 355 686
355 702 355 704

355 707 355 034
355 704 355 706
355 705 355 703

355 709
355 704
355 705
355 642
355 694
355 686
Qty Wt.
355 034 Pipe 1 0.3

355 252 Screw 33 -
355 547 Pipe clamp 34 -
355 642 Pipe 2 0.8
355 694 Pipe 2 1.1
355 702 Support 5 -
355 703 Support 26 0.2
355 704 Washer 96 -
355 705 Screw 62 -
355 706 Nut 26 -
355 707 Ball valve 2 0.1
355 709 Pipe 1 0.2
DBAE577326-
Edition: A
Page: 3(3)
Updated: 06.06.2012
View A
355 249
355 252
355 547
355 266
355 249 355 249
355 252 355 548
355 547 355 710
Qty Wt.
355 249 Pipe clamp 34 -

355 252 Screw 33 -
355 266 Pipe union 1 0.1
355 547 Pipe clamp 34 -
355 548 Screw 1 -
DBAE577326-
DBAE577326-
Edition: C
Page: 1(2)
Updated: 01.07.2010
Starting air pipe
Free End
357 001
357 008
357 009
357 092
357 093
357 094
357 095
Qty Wt.
357 001 Pipe 1 6.6

357 008 Screw 2 -
357 009 Clamp 1 -
357 092 Nut 4 -
357 093 Flange 1 1.8
357 094 Screw 4 0.1
357 095 Gasket 1 -
DBAE577326-
Edition: C
Page: 2(2)
Updated: 01.07.2010
Starting air pipe
View A
357 091
357 190
357 191
357 091 357 362
357 100 357 090
357 091
Qty Wt.
357 090 Screw 4 -

357 091 Nut 9 -
357 100 Screw 1 -
357 190 Gasket 1 -
357 191 Screw 4 -
357 362 Pipe clamp 1 4.8
DBAE577326-
Edition: A
Page: 1(1)
Updated: 08.11.2010
Turning device, pipes
357 515
357 514
357 506
357 517
357 513 357 518
357 051 357 048

357 052
357 048 357 516

357 049
357 047 357 050 357 518
357 046 357 505 357 519
Qty Wt.
357 046 Pipe 1 0.6

357 047 Pipe 1 0.7
357 048 Pipe clamp 3 0.1
357 049 Screw 2 -
357 051 Bracket 2 0.3
357 052 Screw 2 -
357 505 Pipe union 1 0.2
357 506 Nut 1 -
357 513 Pipe union 2 0.1
357 514 Pipe 1 0.5
357 515 Pipe 1 0.5
357 516 Bracket 1 0.1
357 517 Screw 1 -
357 518 Washer 2 -
357 519 Screw 1 -
DBAE577326-
DBAE577326-
Edition: D
Page: 1(4)
Updated: 06.09.2017
Starting air system
357 021
357 036
357 192
357 033
357 039
357 016
357 281
357 065
357 284
Qty Wt.
357 016 Pipe 1 3.5

357 021 Nut 12 -
357 033 Clamp 2 1.4
357 036 Gasket 3 -
357 039 Screw 4 0.1
357 065 Pipe clamp 2 0.2
357 192 Screw 4 -
357 281 Pipe 1 0.3
357 284 Screw 4 -
DBAE577326-
Edition: D
Page: 2(4)
Updated: 06.09.2017
Starting air system
357 041 357 023 357 1016

357 042 357 072 357 1167
357 043
357 044 357 017
357 064 357 1018
357 081 357 1014
357 026
CV 153-1
357 532 223 119
CV 321 357 031
357 456 357 030
PT 311-1 CV 153-2
357 533
507 1561
PT 311-2
507 1562
507 1563
Qty Wt. Qty Wt.
223 119 Pipe union 1 - CV153-2 Solenoid valve, stop (1) 1 -

357 017 Main starting valve 1 7.1 CV321 Solenoid valve (1) 1 -
357 023 Pipe union 1 - PT311-1 Pressure sensor 1 -
357 026 Pipe union 1 0.2 PT311-2 Pressure sensor 1 -
357 030 Pipe union 2 0.3
357 031 Pipe union 1 - NOTE! (1) Valve body is not included.
357 041 Flame arrester 1 0.4
357 042 Flange 1 1.0
357 043 Screw 4 -
357 064 O-ring 1 -
357 081 Pipe union 5 0.2
357 456 Valve body 1 -
357 1014 Pipe union 1 -
357 1016 Pipe union 1 -
357 1018 Pipe union 1 -
357 1167 Pipe union 1 -
507 1561 Pressure gauge valve 1 0.3
507 1562 Throttle valve 1 -
507 1563 Adapter 1 0.3
CV153-1 Solenoid valve, stop (1) 1 -
DBAE577326-
Edition: D
Page: 3(4)
Updated: 06.09.2017
Starting air system
A
357 1002
357 1008
357 207 357 300
357 998 357 1018 357 1000
357 466 357 1025 357 1010
357 467 357 014 357 079
357 081 357 467
357 1026 357 999
357 1015 357 295
357 1005 357 1241
357 1020 357 996
357 081 357 1009
357 1003 357 1019
357 1024 357 081
357 698 357 1003 357 1001 357 997
357 1017 357 1021 357 1006 357 1007
Qty Wt. Qty Wt.
357 014 Pipe 1 0.1 357 1015 Pipe union 1 -

357 079 Non-return valve 1 0.2 357 1017 Pipe union 1 0.2
357 081 Pipe union 5 0.2 357 1018 Pipe union 1 -
357 207 Screw 1 - 357 1019 Pipe union 1 0.2
357 295 Pipe union 1 0.1 357 1020 O-ring 3 -
357 300 Pipe 1 0.1 357 1021 O-ring 1 -
357 466 Pipe clamp 1 - 357 1024 Flexible hose 2 0.2
357 467 Screw 2 - 357 1025 Pipe 1 -
357 698 Adapter 1 0.1 357 1026 Pipe 1 0.1
357 996 Pipe clamp 1 0.9 357 1241 Pipe union 1 -
357 997 Adapter 1 4.6
357 998 Clamp 2 0.2
357 999 Pipe clamp 1 0.2
357 1000 Pipe clamp 2 0.2
357 1001 Vibration damper 4 -
357 1002 Pipe clamp 1 0.1
357 1003 Screw 4 -
357 1005 Screw 4 -
357 1006 Screw 8 -
357 1007 Screw 4 -
357 1008 Screw 1 -
357 1009 Screw 2 -
357 1010 Screw 2 -
DBAE577326-
Edition: D
Page: 4(4)
Updated: 06.09.2017
Starting air system
357 1022 357 029 357 021 357 028 357 021
357 1024 357 037 357 022 357 038 357 027
357 081 357 020
357 392
357 1024 357 034
357 1013 357 045
387 002 357 063
357 698
357 1017
357 1011
387 002 357 036
357 1012
387 002
357 081
357 1023 357 019 357 015
357 018
Qty Wt. Qty Wt.

357 015 Pipe 1 0.3 357 1023 Flexible hose 1 0.2

357 018 Pipe 1 0.3 357 1024 Flexible hose 2 0.2
357 020 Screw 4 -
357 021 Nut 12 -
357 022 Screw 4 -
357 027 Valve 1 0.2
357 028 Safety valve 1 1.2
357 034 Non-return valve 1 0.5
357 036 Gasket 3 -
357 037 Screw 8 -
357 038 Screw 4 -
357 063 O-ring 2 -
357 081 Pipe union 5 0.2
357 392 Pipe 1 -
357 698 Adapter 1 0.1
357 1011 Screw 1 -
357 1012 Screw 1 -
357 1013 Screw 1 -
357 1017 Pipe union 1 0.2
357 1022 Flexible hose 1 0.2
DBAE577326-
Edition: D
Page: 1(1)
Updated: 11.01.2010
Leak oil pipe, dirty, free end
B-BANK A-BANK
358 578 358 578
358 013 358 034
* 358 121 358 121 *

* 358 122 358 122 *
* 358 119 358 119 *
* 358 120 358 120 *
Qty Wt.
358 013 Leak oil pipe 1 0.6

358 034 Leak oil pipe 1 0.6
358 119 Pipe union *) 2 0.2
358 120 Plug *) 2 -
358 121 Plug *) 2 -
358 122 Pipe union *) 2 -
358 578 Pipe union 2 0.3
NOTE! (*) Optional.
DBAE577326-
DBAE577326-
Edition: A
Page: 1(2)
Updated: 11.05.2009
Connection pieces for oil pipe
358 044 358 020 358 021

358 023
358 026
358 025
358 005
358 019
358 027
358 598
358 599
358 065
Detail X
B
358 023
Qty Wt.

358 019 Pipe 1 0.5
358 020 Flexible hose 1 -
358 023 O-ring 5 -
358 026 Screw 2 -
358 027 Pipe 1 0.2
358 598 Clamp 1 -
358 599 Screw 1 -
DBAE577326-
Edition: A
Page: 2(2)
Updated: 11.05.2009
Connection pieces for oil pipe
View A View B
358 024
358 024 358 064

358 028 358 066
358 017
358 005
358 022 358 022
Qty Wt.

358 022 O-ring 6 -
358 024 Screw 2 -
358 064 Plug 2 -
DBAE577326-
Edition: B
Page: 1(1)
Updated: 05.08.2011
Leak oil pipe, clean, free end
B-BANK A-BANK
* 358 042 358 042 *
358 041 358 040
* 358 116 358 116 *

* 358 117 358 117 *
Qty Wt.
358 040 Pipe 1 1.4

358 041 Pipe 1 1.0
358 116 Pipe union 2 0.2
358 117 Plug 2 0.1
NOTE! (*) Optional.
DBAE577326-
DBAE577326-
Edition: A
Page: 1(2)
Updated: 19.05.2014
Leak fuel pipes
358 147 358 146
358 145
Qty Wt.
358 145 Pipe 1 2.6

358 146 Pipe 1 1.9
358 147 Pipe 1 1.9
DBAE577326-
Edition: A
Page: 2(2)
Updated: 19.05.2014
Leak fuel pipes
358 149 358 149

358 152 358 152
358 148
358 151 358 151 358 150

358 154 358 154 358 153
358 155 358 155 358 154
358 157 358 157 358 155 358 152
358 158 358 158 358 157 358 159
Qty Wt.
358 148 Pipe union 1 0.6

358 149 Reduction union 2 0.2
358 150 Pipe clamp 2 0.3
358 151 Pipe clamp 2 2.5
358 152 Pipe union 3 0.2
358 153 Screw 4 -
358 154 Nut 8 -
358 155 Screw 8 -
358 157 Washer 16 -
358 158 Screw 4 -
358 159 Plug 1 0.1
DBAE577326-
Edition: A
Page: 1(5)
Updated: 11.08.2008
Cleaning device for turbocharger
372 540 372 538
372 536 372 601 372 053

372 372
372 544
372 544
372 541
372 654
372 302
X 372 651
372 642
372 640
372 291
372 302
372 640
372 644
372 653
372 669
372 643
372 652
Qty Wt.
372 053 Pipe 1 -

372 536 Pipe 1 -
372 538 Gasket 2 -
372 540 Screw 8 -
372 544 Screw 4 -
372 640 Pipe 3 -
372 642 Pipe 1 -
372 643 Pipe 1 -
372 644 Pipe 1 -
372 651 Stud 2 -
372 652 Straight union 2 -
372 653 Angle union 1 -
372 669 Screw 1 -
DBAE577326-
Edition: A
Page: 2(5)
Updated: 11.08.2008
Detail X
372 646
372 650 372 018
372 659 372 127
372 660 372 645

372 661 372 662
372 663
372 672
372 667 372 126
372 668 372 376
372 647
372 661
372 302 372 663
372 648 372 649 372 664 372 657 372 666
372 667 372 658 372 668
372 670
Qty Wt. Qty Wt.
372 018 Ball valve 2 - 372 672 Screw 2 -

372 376 Screw 4 -
372 645 Pipe 1 -
372 646 Pipe 1 -
372 647 Pipe 1 -
372 648 Pipe 1 -
372 649 Pipe 1 -
372 650 Pipe 2 -
372 657 T-union 1 -
372 659 T-union 1 -
372 661 Pipe clamp 12 -
372 662 Support 2 -
372 663 Fixing piece 7 -
372 666 Screw 5 -
372 667 Screw 5 -
372 668 Screw 6 -
372 670 Screw 2 -
DBAE577326-
Edition: A
Page: 3(5)
Updated: 11.08.2008
DBAE577326-
Edition: A
Page: 4(5)
Updated: 11.08.2008
Detail Y Section A-A
372 665
372 671
372 656 372 302 372 654
372 655
Qty Wt.

372 671 Screw 4 -
DBAE577326-
Edition: A
Page: 5(5)
Updated: 11.08.2008
View B
372 651
372 640
372 291
372 652
372 661
372 666
372 641
Qty Wt.

372 640 Pipe 3 -
372 641 Pipe 1 -
372 651 Stud 2 -
372 652 Straight union 2 -
372 661 Pipe clamp 12 -
372 666 Screw 5 -
DBAE577326-
DBAE577326-
Edition: B
Page: 1(2)
Updated: 13.07.2009
Ventilation valve
See 378-
A 378 016
378 014
378 015 378 019
378 018
View A
378 017
378 045
Qty Wt.
378 014 Cover 1 -

378 015 Screw 17 -
378 016 Cover 1 -
378 017 Screw 3 -
378 018 Support 1 -
378 019 Cover 1 -
378 045 Straight lead-through 1 -
DBAE577326-
Edition: B
Page: 2(2)
Updated: 13.07.2009
Ventilation valve
See 107-
378 021
378 015
378 020
Qty Wt.
378 015 Screw 17 -

378 020 Screw 1 -
378 021 Screw 1 -
DBAE577326-
Edition: B
Page: 1(1)
Updated: 13.09.2012
Crankcase breather
378 001
387 031
378 005
378 002
378 012
387 020
Qty Wt.
378 001 Pipe 1 -

378 002 Ventilation valve, lower 1 -
part
378 005 Screw 4 -
378 012 Screw 4 -
DBAE577326-
DBAE577326-
Edition: P
Page: 1(2)
Updated: 31.05.2013
Chemicals
Qty Wt. Qty Wt.

387 001 Glue compound 1 - 387 024 Glue compound 1 -

387 006 Glue compound 1 - 387 029 Assembly compound 1 -
387 014 Glue compound 1 - NOTE! When ordering chemicals, please
387 015 Glue compound 1 - use the spare part numbers found in
the specific sections.
DBAE577326-
Edition: P
Page: 2(2)
Updated: 31.05.2013
Chemicals
Qty Wt. Qty Wt.

387 036 Glue compound 1 - 387 060 Sealant 1 -

387 038 Contact lubrication 1 - 387 062 Glue compound 1 -
387 040 Glue compound 1 - NOTE! When ordering chemicals, please
387 041 Contact lubrication 1 - use the spare part numbers found in
the specific sections.
387 048 Corrosion protection 1 -
387 049 Cleaner 1 -
387 052 Activator 1 -
DBAE577326-
Edition: A
Page: 1(1)
Updated: 25.04.2017
Maintenance kit for solenoid valve
452 101
Qty Wt.
452 101 Maintenance kit * 1 -
NOTE! *) For solenoid valve type 2489/41
DBAE577326-
DBAE577326-
Edition: A
Page: 1(1)
Updated: 23.11.2016
Maintenance kit for solenoid valve
452 102
Qty Wt.
452 102 Maintenance kit * 1 -
NOTE! *) For solenoid valve type 2491/41
DBAE577326-
DBAE577326-
Edition: A
Page: 1(1)
Updated: 07.11.2003
Running-in filter
100 131
471 117
471 120
471 563
471 113
471 564
471 119
471 116 471 124
471 115
471 113
471 123
471 112
Qty Wt.
471 124 Running-in filter 1 15.0

471 112 Flange 1 5.0
471 113 O-ring 2 -
471 115 Filter cartridge 1 0.2
471 116 Pipe 1 3.0
471 117 Flange 1 4.5
471 119 Screw 2 -
471 120 Nut 2 -
471 563 Screw 3 -
471 564 Adapter 1 6.0
100 131 O-ring 1 -
471 123 Screw 2 -
DBAE577326-
DBAE577326-
Edition: C
Page: 1(6)
Updated: 01.04.2009
Lubricating oil filter
471 565 471 088
471 062 471 108 471 063

471 085 471 064 471 077
471 086 471 566
471 568
471 057
See page 4
471 127
See page 4 471 056
471 590
471 591
471 092
471 583
471 088
471 060 471 081 471 584
471 108
471 103 471 588
471 101
Qty Wt.
471 056 Lubricating oil filter 1 -

471 057 Cover 1 -
471 060 Tube stack 1 -
471 062 Plate 1 -
471 063 Filter cartridge 78 -
471 077 Valve 6 -
471 081 Ball bearing 2 -
471 085 Screw 8 -
471 086 Nut 8 -
471 088 Screw 3 -
471 092 Screw 3 -
471 101 O-ring 1 -
471 103 O-ring 2 -
471 108 Gasket 3 -
471 127 Cord ring 156 -
471 565 Housing 1 -
471 583 Pin 1 -
471 584 Pin 2 -
471 588 Locking ring 2 -
471 590 Washer 2 -
471 591 Support disc 2 -
DBAE577326-
Edition: C
Page: 2(6)
Updated: 01.04.2009
471 086 471 568 471 066 471 067 471 090
471 085 471 569 471 090 471 566
471 587 471 062 471 091
471 081
471 588
471 088 471 108 471 092 471 585 471 577 471 101 471 103 471 586
Qty Wt.
471 062 Plate 1 -

471 066 Plate 1 -
471 067 Shaft 2 -
471 085 Screw 8 -
471 086 Nut 8 -
471 088 Screw 3 -
471 090 Screw 6 -
471 091 Screw 6 -
471 092 Screw 3 -
471 101 O-ring 1 -
471 103 O-ring 2 -
471 108 Gasket 3 -
471 577 O-ring 2 -
471 585 Bracket 2 -
471 586 Pipe 1 -
DBAE577326-
Edition: C
Page: 3(6)
Updated: 01.04.2009
471 103 471 061 471 102
471 569 471 090

471 064 471 586 471 063 471 077 471 587
471 127 471 081

471 588
471 090 471 060 471 127 471 577 471 585
471 067
471 092 471 091 471 584 471 596
Qty Wt.
471 060 Tube stack 1 -

471 061 Plate 1 -
471 067 Shaft 2 -
471 077 Valve 6 -
471 090 Screw 6 -
471 091 Screw 6 -
471 092 Screw 3 -
471 102 O-ring 1 -
471 103 O-ring 2 -
471 127 Cord ring 156 -
471 577 O-ring 2 -
471 584 Pin 2 -
471 585 Bracket 2 -
471 586 Pipe 1 -
471 596 Guide ring 1 -
DBAE577326-
Edition: C
Page: 4(6)
Updated: 01.04.2009
471 596 471 102 471 599 471 565
471 103 471 095
471 061 471 553
471 558 471 090 471 075
471 091 471 080

471 560
471 592 471 074
471 554
471 580 471 069
471 559 471 105
471 581
471 561 471 097

471 096
471 555 471 585
471 592
471 582
471 593
471 556
471 594
471 557
471 073
Qty Wt. Qty Wt.
471 061 Plate 1 - 471 565 Housing 1 -

471 069 Flange 1 - 471 580 Plug 1 -
471 073 Gear wheel 1 - 471 581 O-ring 1 -
471 074 Bush 1 - 471 582 O-ring 1 -
471 075 Bush 1 - 471 585 Bracket 2 -
471 080 Spring 1 - 471 592 Grooved pin 2 -
471 090 Screw 6 - 471 593 Screw 2 -
471 091 Screw 6 - 471 594 Coupling 1 -
471 095 Screw 2 - 471 596 Guide ring 1 -
471 096 Screw 4 - 471 599 Guide 1 -
471 097 Screw 1 -
471 102 O-ring 1 -
471 103 O-ring 2 -
471 105 O-ring 1 -
471 553 Screw 1 -
471 554 O-ring 1 -
471 555 Gasket 1 -
471 556 Spring washer 3 -
471 557 Screw 3 -
471 558 Screw 2 -
471 559 Bush 1 -
471 560 Tension ring 1 -
471 561 Inspection glas 1 -
DBAE577326-
Edition: C
Page: 5(6)
Updated: 01.04.2009
A
Section A-A
471 089 471 087 471 107
B
471 070
471 071
A
471 094
Section B-B
471 073
471 099
471 109
471 595 471 594
Qty Wt.
471 070 Gearbox housing 1 -

471 071 Turbine rotor 1 -
471 073 Gear wheel 1 -
471 087 Cover 1 -
471 089 Screw 4 -
471 094 Screw 1 -
471 099 Washer 1 -
471 107 O-ring 1 -
471 109 Nut 1 -
471 594 Coupling 1 -
471 595 Screw 4 -
DBAE577326-
Edition: C
Page: 6(6)
Updated: 01.04.2009
474 161 474 012 471 577 471 108
474 098 471 105
471 107
471 126
471 127
471 555
471 582
471 589 471 554

471 103
471 101 471 102 471 581
Qty Wt.

471 101 O-ring 1 -
471 102 O-ring 1 -
471 103 O-ring 2 -
471 105 O-ring 1 -
471 107 O-ring 1 -
471 108 Gasket 3 -
471 127 Cord ring 156 -
471 554 O-ring 1 -
471 555 Gasket 1 -
471 577 O-ring 2 -
471 581 O-ring 1 -
471 582 O-ring 1 -
471 589 O-ring 2 -
474 012 O-ring 1 -
474 098 O-ring 1 -
474 161 O-ring 1 -
DBAE577326-
Edition: B
Page: 1(7)
Updated: 15.03.2016
Centrifugal filter
473 001
Qty Wt.
473 001 Centrifugal filter 1 -
DBAE577326-
Edition: B
Page: 2(7)
Updated: 15.03.2016
Centrifugal filter
473 035 473 036
473 033
Qty Wt.
473 033 Cover, complete 1 5.5

473 035 Cover clamp ring 1 1.2
473 036 Body, compl. 1 15.8
DBAE577326-
Edition: B
Page: 3(7)
Updated: 15.03.2016
Centrifugal filter
473 072 473 120 473 122
473 121 473 123
473 033
473 124
473 079
473 073
473 074
473 073
473 076
473 074
Qty Wt.
473 033 Cover, complete 1 5.5

473 072 Sight glass kit 1 0.1
473 121 Sight glass * 1 -
473 073 Cover bearing * 1 -
473 074 Circlip * 1 -
473 124 Cover * 1 -
473 079 Bearing kit (1) 1 0.3
473 073 Cover bearing * 1 -
473 074 Circlip * 1 -
473 076 Bearing * (2) 1 -
NOTE! (1) Glue compound included.

NOTE! (2) Illustrated on page 4.
NOTE! Spare parts marked with * can not
be ordered separately
DBAE577326-
Edition: B
Page: 4(7)
Updated: 15.03.2016
Centrifugal filter
473 082
473 036
473 139
473 076
473 127 473 130 473 085
473 131 473 129
473 128
473 085
473 064
473 129 473 083
Qty Wt.
473 036 Body, compl. 1 15.8

473 064 Valve, compl. 1 2.5
473 083 O-ring * 1 -
473 076 Bearing * 1 -
473 082 O-ring * 1 -
473 128 Housing * 1 -
473 129 Plug * 2 -
473 130 Nut * 1 -
473 131 Stop screw * 1 -
473 139 Plug * 1 -

DBAE577326-
Edition: B
Page: 5(7)
Updated: 15.03.2016
Centrifugal filter
473 071
473 132
473 032 473 077 473 134

473 133
473 138 473 135
473 066 473 069
473 067
473 136
473 063
473 062
473 078
473 137
Qty Wt.
473 032 Rotor, compl. 1 12.1

473 063 Paper insert kit (1) 1 0.1
473 067 Rotor tube 1 3.7
473 071 Rotor subassembly 1 6.1
473 062 Nozzle * 4 -
473 069 O-ring * 1 -
473 134 Grub screw * 1 -
473 135 Spindle * 1 -
473 136 Rotor base * 1 -
473 137 Pelton wheel * 1 -
473 077 Rotor cover 1 2.0
473 066 O-ring * 1 -
473 132 Nut * 1 -
473 133 Rotor cover * 1 -
473 078 Cone 1 0.3
NOTE! (1) Pack of 25

DBAE577326-
Edition: B
Page: 6(7)
Updated: 15.03.2016
Centrifugal filter
473 066
473 081
473 082
473 069
473 127 473 085
473 085
473 083
Qty Wt.

473 066 O-ring (1) 1 -
473 069 O-ring (1) 1 -
473 082 O-ring (1) 1 -
473 083 O-ring (1) 1 -
473 085 Sealing ring (1) 2 -
473 127 Sealing ring (1) 1 -
NOTE! (1) Parts included in set are not

delivered separately.
DBAE577326-
Edition: B
Page: 7(7)
Updated: 15.03.2016
Centrifugal filter
473 140
473 139
473 127
Qty Wt.
473 140 Tube assembly removal 1 -

kit
473 127 Sealing ring (1) 1 -
473 139 Plug (1) 1 -
NOTE! (1) Parts included in set are not

delivered separately.
DBAE577326-
DBAE577326-
Edition: B
Page: 1(1)
Updated: 07.12.2011
Oil sample valve
352 378
352 304
352 379
352 380
474 104
352 377
352 381
Qty Wt.
474 104 Valve 1 0.4

352 304 Pin 1 -
352 377 Housing 1 0.3
352 378 Spindle 1 0.1
352 379 Nut 1 -
DBAE577326-
DBAE577326-
Edition: D
Page: 1(1)
Updated: 30.05.2012
Fastening for lube oil module
474 175
474 174
474 176 474 176
474 177 474 177

387 025
474 187
474 181
474 183
474 188
Qty Wt.
474 174 Screw 9 0.4

474 175 Screw 5 0.6
474 176 Nut 7 -
474 177 Distance sleeve 7 0.1
474 181 Flange 1 0.5
474 183 Screw 4 -
474 187 Screw 2 0.2
474 188 Gasket 1 -
DBAE577326-
DBAE577326-
Edition: C
Page: 1(7)
Updated: 22.01.2013
Lube oil module
471 056
474 007 474 003 474 116 474 123
474 194
474 137 474 045 474 161
474 195
474 162
474 123
474 119
474 161
474 120
352 063 474 119
474 046
474 120
473 001
474 104
473 015
474 052 474 059
474 056 474 056 183 005 474 134 473 013
B A
474 077 474 117 183 086 474 147 473 014
474 083 474 161 474 186 474 148
Qty Wt. Qty Wt.
183 005 O-ring 5 - 474 123 Screw 17 -

183 086 Thermostatic element 5 - 474 134 Flange 1 602
assembly 474 137 Retainer ring 1 0.3
352 063 Pipe 1 10.5 474 147 Screw 8 -
471 056 Lubricating oil filter (1) 1 - 474 148 Nut 8 -
473 001 Centrifugal filter (2) 1 35.0 474 161 O-ring 7 -
473 013 O-ring 1 - 474 162 O-ring 2 -
473 014 O-ring 2 - 474 186 Screw 19 -
473 015 O-ring 1 - 474 194 Sealing ring 2 -
474 003 Tube stack 1 - 474 195 Plug 2 0.5
474 007 Gasket 5 0.1
474 045 Housing 1 430 NOTE! (1) See section 471-
474 046 End flange 1 300 NOTE! (2) See section 473-
474 052 Screw 8 -
474 056 Screw 12 -
474 059 Screw 4 -
474 077 O-ring 2 -
474 083 Flange 2 6.5
474 104 Valve 1 0.5
474 116 Support 1 8.0
474 117 Flange 1 -
474 119 Plug 13 -
DBAE577326-
Edition: C
Page: 2(7)
Updated: 22.01.2013
Lube oil module
474 170
474 185
474 052
474 168 474 123
474 144
474 164
474 190
474 142
474 140
474 141 474 144
474 144 474 164
474 164 474 145
474 143 474 173 474 198
474 199
Qty Wt.
474 052 Screw 8 -

474 123 Screw 17 -
474 140 Pipe 1 1.0
474 141 Pipe 1 5.8
474 142 Pipe 1 6.0
474 143 Pipe 1 5.8
474 144 Screw 8 -
474 145 Screw 2 -
474 164 O-ring 6 -
474 168 Support 1 -
474 170 Screw 4 0.1
474 173 Bracket 1 638
474 185 Washer 4 -
474 190 Flange 4 -
474 198 Plug 1 -
DBAE577326-
Edition: C
Page: 3(7)
Updated: 22.01.2013
Lube oil module
474 057 474 205

474 084 474 206
474 208
474 206
474 207
474 209
474 119
474 120
Qty Wt.
474 057 Screw 2 0.1

474 084 Clamp 2 1.4
474 119 Plug 13 -
474 205 Screw 2 -
474 206 Washer 4 -
474 207 Support 1 2.3
474 208 Pipe clamp 1 0.8
474 209 Screw 2 -
DBAE577326-
Edition: C
Page: 4(7)
Updated: 22.01.2013
Lube oil module
474 151
474 161 474 162
474 114 474 119
474 119 474 120
474 120
474 210 474 114
474 057 474 161
474 084 474 114
474 186
474 158
474 159
474 123
474 166
Qty Wt.
474 057 Screw 2 0.1

474 084 Clamp 2 1.4
474 114 Screw 8 0.1
474 119 Plug 13 -
474 123 Screw 17 -
474 151 Screw 1 0.3
474 158 Ring 1 0.1
474 159 O-ring 1 -
474 161 O-ring 7 -
474 162 O-ring 2 -
474 166 O-ring 1 0.1
474 186 Screw 19 -
474 210 Screw 1 0.2
DBAE577326-
Edition: C
Page: 5(7)
Updated: 22.01.2013
Lube oil module
474 115
474 114
474 098
474 200
474 115
474 200 474 114
474 161
474 161
474 114
474 149 474 167
474 007
474 140
474 144
474 164
474 147
474 148 474 150
Qty Wt.
474 007 Gasket 5 0.1

474 098 O-ring 1 -
474 114 Screw 8 0.1
474 115 Screw 4 -
474 140 Pipe 1 1.0
474 144 Screw 8 -
474 147 Screw 8 -
474 148 Nut 8 -
474 149 Screw 3 0.3
474 150 Screw 2 0.4
474 161 O-ring 7 -
474 164 O-ring 6 -
474 167 Pin 2 -
474 200 Washer 4 -
DBAE577326-
Edition: C
Page: 6(7)
Updated: 22.01.2013
Lube oil module
View A View B
474 155 474 165 474 154 474 147

473 014
474 157 474 153 474 155
Qty Wt.
473 014 O-ring 2 -

474 147 Screw 8 -
474 153 Plug 1 0.1
474 154 O-ring 1 -
474 155 O-ring 5 -
474 157 O-ring 1 -
474 165 O-ring 1 -
DBAE577326-
Edition: C
Page: 7(7)
Updated: 22.01.2013
Lube oil module
474 120 473 015
473 013 474 007 474 159 474 098
474 162 474 157
474 154 474 043
474 155 474 194 474 199

474 077
474 165 474 161
473 014
474 166
183 005 474 164
Qty Wt.
474 043 Sealing set 1 1.0

183 005 O-ring 5 -
473 013 O-ring 1 -
473 014 O-ring 2 -
473 015 O-ring 1 -
474 007 Gasket 5 0.1
474 077 O-ring 2 -
474 098 O-ring 1 -
474 154 O-ring 1 -
474 155 O-ring 5 -
474 157 O-ring 1 -
474 159 O-ring 1 -
474 161 O-ring 7 -
474 162 O-ring 2 -
474 164 O-ring 6 -
474 165 O-ring 1 -
474 166 O-ring 1 0.1
DBAE577326-
DBAE577326-
Edition: A
Page: 1(1)
Updated: 05.10.2007
Charge air cooler
476 001 476 009
Qty Wt.
476 001 Charge air cooler 1 -

476 009 Sealing set (1) 1 -
NOTE! (1) When ordering, please state the

serial number and the manufacturer
of the air cooler.
DBAE577326-
DBAE577326-
Edition: D
Page: 1(2)
Updated: 07.06.2011
Charge air cooler assembly
B
C
Section C-C C
A
476 015
476 016 476 016
476 016 476 016
476 032 476 032
476 030 476 030

476 031 476 031
Qty Wt.
476 015 Screw 10 -

476 016 Screw 28 -
476 032 Pipe 2 -
DBAE577326-
Edition: D
Page: 2(2)
Updated: 07.06.2011
Charge air cooler assembly
Section A-A Section B-B View E

476 048
E
476 049
476 021
156 161
476 020
476 001 476 024
476 033
387 020 476 025

476 027
476 026 476 020
476 055
476 019 476 052
476 023 476 053
476 022
476 017
476 028
476 018
476 022
476 028
Qty Wt.
156 161 O-ring 4 -

476 001 Charge air cooler 1 -
476 017 Plug 4 -
476 019 O-ring 4 -
476 020 Cover 1 -
476 021 Cover 1 -
476 022 O-ring 2 -
476 023 O-ring 4 -
476 024 Flange 4 -
476 025 Screw 16 -
476 026 Plug 4 -
476 028 Screw 64 -
476 033 Washer 16 -
476 048 Plug 2 -
476 052 Plug 1 -
476 055 Plug 2 -
DBAE577326-
Edition: A
Page: 1(1)
Updated: 29.06.2006
Cover for fuel oil pipes
482 043
482 030
482 031
482 037
482 052
482 041
482 040
482 043
482 051
Qty Wt.
482 030 Cover 1 -

482 031 Screw 8 -
482 037 Washer 8 -
482 040 Cover 1 -
482 041 Screw 1 -
482 043 Washer 15 -
482 051 Nut 7 -
DBAE577326-
DBAE577326-
Edition: A
Page: 1(8)
Updated: 26.10.2010
Turning device
483 008
483 049
483 057
483 055
483 056
483 058
483 053
483 001
214 001
214 007
Qty Wt.
483 001 Turning device 1 84.0

214 001 Start blocking device 1 2.0
214 007 Screw 4 -
483 049 Screw 12 -
483 053 Screw 7 -
483 055 Plug bolt 2 -
483 057 Breather 1 -
483 058 Oil level gauge 1 -
DBAE577326-
Edition: A
Page: 2(8)
Updated: 26.10.2010
Turning device
483 143 483 052 483 043
483 025 483 014 483 029
483 062
483 015
483 034
483 016
483 034
483 037
483 012
483 050
387 025
483 026 483 143 483 025 483 062

Qty Wt.
483 012 Cover 1 2.0

483 014 Primary gear 1 2.0
483 015 Gear 1 2.0
483 016 Worm 1 2.0
483 025 Flange 2 12.6
483 026 Hand wheel 1 1.1
483 029 Washer 1 -
483 034 Roller bearing 2 2.0
483 037 Shaft seal 1 2.0
483 043 Retaining ring 1 2.0
483 050 Screw 6 -
483 052 Screw 1 -
483 062 Locking element 2 -
483 143 Screw 2 -
DBAE577326-
Edition: A
Page: 3(8)
Updated: 26.10.2010
Turning device
483 143
483 025
483 062
483 015
483 034
483 016
483 034
483 037
483 012
483 050
483 026
483 062
483 025
483 143
Qty Wt.
483 012 Cover 1 2.0

483 015 Gear 1 2.0
483 016 Worm 1 2.0
483 025 Flange 2 12.6
483 026 Hand wheel 1 1.1
483 034 Roller bearing 2 2.0
483 037 Shaft seal 1 2.0
483 050 Screw 6 -
483 062 Locking element 2 -
483 143 Screw 2 -
DBAE577326-
Edition: A
Page: 4(8)
Updated: 26.10.2010
Turning device
483 008
483 014
483 043
483 029
483 052
Qty Wt.

483 014 Primary gear 1 2.0
483 029 Washer 1 -
483 043 Retaining ring 1 2.0
483 052 Screw 1 -
DBAE577326-
Edition: A
Page: 5(8)
Updated: 26.10.2010
Turning device
483 138
483 141
483 140
483 137
483 139
483 133
483 144
Qty Wt.
483 133 Transfer fork 1 2.0

483 137 Pin 1 2.0
483 138 Spring rod 1 2.0
483 139 Support 1 2.0
483 140 Push rod 1 2.0
483 141 Circlip 2 -
483 144 Pin 1 -
DBAE577326-
Edition: A
Page: 6(8)
Updated: 26.10.2010
Turning device
Section A - A
483 033
483 017
483 036
483 048 483 135 483 134
483 030
483 033
483 035
483 019
483 061
483 053
483 020
387 025 483 136
Qty Wt.
483 017 Worm wheel 1 2.0

483 019 Shaft 1 2.0
483 030 Cover 1 -
483 033 Ball bearing 2 2.0
483 036 Shaft seal 1 2.0
483 048 Screw 8 -
483 053 Screw 7 -
483 134 Tap of transfer fork 2 2.0
483 135 Bushing 1 2.0
483 136 Bushing 1 2.0
DBAE577326-
Edition: A
Page: 7(8)
Updated: 26.10.2010
Turning device
483 033 483 048 483 017 483 019 483 061 483 033
483 053
483 036 483 135 483 136 483 020 483 134 483 035 483 030
Qty Wt.
483 017 Worm wheel 1 2.0

483 019 Shaft 1 2.0
483 030 Cover 1 -
483 036 Shaft seal 1 2.0
483 048 Screw 8 -
483 053 Screw 7 -
483 134 Tap of transfer fork 2 2.0
483 135 Bushing 1 2.0
483 136 Bushing 1 2.0
DBAE577326-
Edition: A
Page: 8(8)
Updated: 26.10.2010
Turning device
483 142
Qty Wt.
483 142 Screw 4 -
DBAE577326-
Edition: C
Page: 1(1)
Updated: 16.09.2011
Equipment for turning device
483 008
483 009 483 006

483 071
483 145
View A
483 146
A
483 148
483 001 483 005
483 149
483 006 483 004
483 002
483 003
Qty Wt.
483 001 Turning device 1 84.0

483 002 Screw 2 -
483 003 Washer 2 -
483 004 Pin 1 -
483 005 Indicator 1 0.2
483 006 Pin 2 -
483 009 Screw 4 -
483 071 Shield 1 0.3
483 145 Screw 2 -
483 146 Washer 2 -
483 148 Screw 3 0.2
483 149 Washer 3 -
DBAE577326-
DBAE577326-
Edition: B
Page: 1(1)
Updated: 19.08.2008
Temperature sensor for exhaust gas
504 130 504 128

504 131 504 129
Qty Wt.
504 128 Temperature sensor 1 -

504 129 Protecting well 1 -
504 130 Fastening 2 -
504 131 Screw 2 -
NOTE! Quantity per cylinder.
DBAE577326-
DBAE577326-
Edition: A
Page: 1(2)
Updated: 17.11.2009
504 009 504 009

504 011 504 011
504 014 504 014
SE 518 SE 528
Qty Wt.
504 009 Cable clamp 14 -

504 011 Screw 14 -
504 014 Steel strip 14 -
SE518 Speed pick-up 1 -
DBAE577326-
Edition: A
Page: 2(2)
Updated: 17.11.2009
Detail X
504 009 504 009

504 011 504 011
504 014 504 014
504 137 504 137
504 254 504 254
TE 511 TE 521
Qty Wt.

504 011 Screw 14 -
504 137 Protecting well 2 0.5
TE511 Temperature sensor 1 0.5
TE521 Temp.transmitter, 1 0.5
exh.gas, before TC
DBAE577326-
Edition: A
Page: 1(1)
Updated: 30.07.2013
Electrical equipment for air bottle
228 038 CV 321 228 055 228 039
228 059 228 059
CV 153-1
ST 173 ST 174
Qty Wt.
228 038 Screw 2 -

228 039 Screw 2 -
228 059 O-ring 2 -
CV153-1 Solenoid valve, stop 1 -
CV321 Solenoid valve 1 -
ST173 Speed pick-up 1 0.5
ST174 Speed pick-up 1 0.5
DBAE577326-
DBAE577326-
Edition: C
Page: 1(2)
Updated: 21.11.2011
Sensors for lube oil
506 1230
506 1303 506 199
506 1231
387 017
506 1205
506 1206
506 1266 506 1300
506 199 506 1301
506 1202
506 1200 506 1197
506 1201
PT 281
Qty Wt.

506 1197 Adapter and test valve 2 -
506 1200 Clamp 2 -
506 1201 Screw 8 -
506 1202 Screw 4 -
506 1205 Pipe clamp 11 -
506 1206 Screw 2 -
506 1230 Flange 2 -
506 1231 Screw 4 -
506 1266 Pipe 1 -
506 1300 Screw 1 -
506 1301 Pin 1 -
506 1303 O-ring 2 -
PT281 Pressure transmitter 1 -
DBAE577326-
Edition: C
Page: 2(2)
Updated: 21.11.2011
Sensors for lube oil
506 1230 506 199

506 1303
506 1231
387 017
506 1205
506 1206
506 1205
506 1263
506 1204
506 1202
506 199 506 1197
506 1201
506 1200
PT 271
Qty Wt.

506 1200 Clamp 2 -
506 1201 Screw 8 -
506 1202 Screw 4 -
506 1204 Steel pipe 1 -
506 1205 Pipe clamp 11 -
506 1206 Screw 2 -
506 1230 Flange 2 -
506 1231 Screw 4 -
506 1263 Screw 1 -
506 1303 O-ring 2 -
PT271 Pressure sensor 1 -
DBAE577326-
Edition: A
Page: 1(1)
Updated: 25.02.2010
Sensors for control air
506 1177
506 1174
506 1187
506 1178
506 1179
506 1182
506 1183
Qty Wt.

506 1177 Screw 4 -
506 1178 Pipe union 1 -
506 1179 Pipe 1 -
506 1182 Pipe clamp 2 -
506 1183 Screw 1 -
DBAE577326-
DBAE577326-
Edition: B
Page: 1(1)
Updated: 07.09.2010
Sensor for crankcase pressure
View A
PT 700
506 021
A 506 996
506 997
506 023
506 182
Qty Wt.

506 023 Pipe 1 -
506 996 Pipe 1 -
DBAE577326-
DBAE577326-
Edition: A
Page: 1(3)
Updated: 15.09.2011
Wiring harness for turbocharger
TE 517
TE 527
TEZ 403 TE 600

TE 403
TEZ 402
TE 402
PT 281
TE 432 PT 471 PT 271
TE 471 PT 471-2
B
506 235 506 233

506 275 506 235
A
Qty Wt.
506 233 Cable set 1 -

506 275 Cable rail 2 -
PT281 Pressure transmitter 1 -
PT471-2 Pressure sensor 1 -
TE402 Temperature sensor, HT 1 -
water, after engine
water, after engine
TE432 Temp.transmitter, HT 1 -
water, after TC
TE471 LT water temperature, 1 -
before charge air cooler
TE517 Temperature sensor 1 -
TEZ402 Temperature sensor, HT- 1 -
water outlet
TEZ403 Temperature sensor, HT- 1 -
water outlet
DBAE577326-
Edition: A
Page: 2(3)
Updated: 15.09.2011
View A
506 186 506 276

506 259
506 966
506 235
506 964
506 163 506 286

506 1298
506 164
506 162
506 1277
506 163
506 168
Qty Wt.
506 162 Box 1 -

506 163 Cable gland 11 -
506 168 Plug 1 -
506 186 Washer 4 -
506 259 Screw 4 -
506 964 Damper 4 -
506 966 Nut 4 -
506 1298 Blind disc 4 -
DBAE577326-
Edition: A
Page: 3(3)
Updated: 15.09.2011
View B
506 235
506 167
506 163
506 166
506 163
506 231
506 232
506 164
506 265
506 1299
Qty Wt.

506 166 Plug 7 -
506 167 Plug 4 -
506 231 Earthing strap 1 -
506 232 Screw 1 -
506 1299 Blind disc 2 -
DBAE577326-
DBAE577326-
Edition: B
Page: 1(4)
Updated: 23.01.2012
Electrical equipment for turbocharger
TE 527 A TE 517
506 268 506 268
506 1014 506 1014
506 269
506 270
506 335
506 271
506 272
506 1294
PT 281
506 274
Qty Wt.

506 269 Fastener 43 -
506 270 Screw 12 -
506 272 Screw 9 -
506 274 Screw 8 -
506 335 Screw 2 -
506 1294 Cable rail 1 0.7
PT281 Pressure transmitter 1 0.8
DBAE577326-
Edition: B
Page: 2(4)
Updated: 23.01.2012
TE 600
506 1013
506 1014
PT 271
506 274
506 264
506 273
506 335 506 269

506 1018
506 288 506 1297
B
Qty Wt.
506 264 Screw 4 -

506 269 Fastener 43 -
506 273 Bracket 1 1.0
506 274 Screw 8 -
506 288 Screw 1 -
506 335 Screw 2 -
506 1013 Protecting cap 7 0.2
506 1018 Screw 30 -
PT271 Pressure sensor 1 0.8
DBAE577326-
Edition: B
Page: 3(4)
Updated: 23.01.2012
Detail X
506 225 506 274
TE 471
PT 471
506 1013
PT 471-2
506 1014
506 226
506 220
506 227
506 221
506 228
506 229
TE 432 506 271 506 222 506 223 506 230
506 1013 506 272 506 224
506 1014 506 1294
Qty Wt. Qty Wt.

506 220 Angle union 1 0.2 NOTE! *) Length needed when ordering.
506 222 Pipe 1 0.1
506 224 Screw 4 -
506 226 Adapter and test valve 1 1.4
506 227 Screw 4 -
506 228 End piece 1 -
506 229 O-ring 1 -
506 230 Screw 2 -
506 272 Screw 9 -
506 274 Screw 8 -
506 1294 Cable rail *) 1 0.7
PT471-2 Pressure sensor 1 0.8
TE432 Temp.transmitter, HT 1 0.3
water, after TC
TE471 LT water temperature, 1 0.3
before charge air cooler
DBAE577326-
Edition: B
Page: 4(4)
Updated: 23.01.2012
View A
View B
TE 402
506 1013
506 1014
TEZ 402
TE 403
506 1013
506 1014
506 318 506 317 506 316
TEZ 403
Qty Wt.
506 316 Screw 4 -

506 317 Bracket 1 9.5
506 318 Screw 6 -
TE402 Temperature sensor, HT 1 0.3
water, after engine
water, after engine
TEZ402 Temperature sensor, HT- 1 0.3
water outlet
TEZ403 Temperature sensor, HT- 1 0.3
water outlet
DBAE577326-
Edition: A
Page: 1(1)
Updated: 19.09.2011
Sensors for multicover, B-bank
LS 103B
506 998
Qty Wt.

LS103B Level switch 1 0.5
DBAE577326-
DBAE577326-
Edition: A
Page: 1(2)
Updated: 17.10.2011
Sensors
Qty Wt.
NOTE! See page 2.
DBAE577326-
Edition: A
Page: 2(2)
Updated: 17.10.2011
Sensors
Detail X
506 300
PT 781 506 304

506 301
506 302
506 293
506 303
506 305
387 020
506 306
506 297
506 315
506 298
387 006
506 299
506 294
506 295
Qty Wt.
506 293 Adapter 1 -

506 315 Valve 1 -
506 294 Pipe 1 -
506 297 Pipe union 1 0.1
506 299 Pipe 1 -
506 300 Plate 1 1.2
506 301 Pipe clamp 1 0.1
506 302 Screw 2 -
506 303 Nut 2 -
506 304 Screw 3 -
506 305 Nut 2 -
506 306 Screw 2 -
DBAE577326-
Edition: C
Page: 1(1)
Updated: 13.08.2015
Sensors for Multicover, A-bank
LS 103A
506 080
TE 101
506 080
506 1186
506 1577
506 1017
506 1574
PT 101-2
506 1575
507 1549
506 1576
506 1580
PT 101
507 1549
Qty Wt.

506 1574 Bracket 1 -
506 1575 Screw 1 -
506 1576 Nut 1 -
506 1577 Screw 1 0.3
507 1549 Pressure gauge valve *) 2 0.5
LS103A Level switch 1 0.5
TE101 Temperature sensor, 1 -
fuel, before engine
NOTE! *) See 507-
DBAE577326-
DBAE577326-
Edition: A
Page: 1(1)
Updated: 24.09.2014
Sensors on pump cover
TE401 PT 401
506 048 507 1549
506 1010
PT 401-2
507 1549
Qty Wt.

water, before engine
NOTE! *) See 507-
DBAE577326-
DBAE577326-
Edition: H
Page: 1(4)
Updated: 07.06.2012
Main bearing temperature sensors
B C A
Section A-A
B C A
507 086
507 087
507 233
387 017
507 158
507 086
507 087
507 233
387 017
Qty Wt.
507 086 Pipe clamp * -

507 087 Screw * -
507 158 Cable gland * -
507 233 Steel strip * -
NOTE! *) See page 4
DBAE577326-
Edition: H
Page: 2(4)
Updated: 07.06.2012
Section B-B
507 086
507 087
507 233
387 017
507 085
Qty Wt.
507 085 Temperature sensor * -

507 087 Screw * -
NOTE! *) See page 4
DBAE577326-
Edition: H
Page: 3(4)
Updated: 07.06.2012
Section C-C
507 086
507 087
387 017
Qty Wt.

507 087 Screw * -
NOTE! *) See page 4
DBAE577326-
Edition: H
Page: 4(4)
Updated: 07.06.2012

12V 16V 18V 20V
507 085 Temperature sensor 8 10 11 12
507 086 Pipe clamp 85 107 118 129
507 087 Screw 78 100 111 122
507 158 Cable gland 8 10 11 12
507 233 Steel strip 16 20 22 24
DBAE577326-
Edition: C
Page: 1(2)
Updated: 17.06.2008
Terminal box
507 1281 507 1059 507 1057 507 1315
507 1052 507 173
507 1060 507 1055 507 1058
Qty Wt.
507 173 Terminal box 1 -

507 1052 Bracket 1 -
507 1057 Terminal strip 25 -
507 1058 End plate 1 -
507 1059 End stopper 2 -
507 1060 Terminal strip rail (1) 1 -
507 1281 Screw 4 -
NOTE! (1) L= 210mm
DBAE577326-
Edition: C
Page: 2(2)
Updated: 17.06.2008
Terminal box
507 1063
507 1054
507 1061
507 1053
Qty Wt.
507 1053 Damper 4 -

507 1061 Nut 4 -
507 1063 Connecting box 1 -
DBAE577326-
Edition: D
Page: 1(2)
Updated: 23.09.2015
Terminal box
507 1061
507 1640 507 1643
507 1060 507 1641 507 1644 507 1645
507 1059
507 1052 507 173
507 1281 507 1055
Qty Wt.
507 173 Terminal box 1 -

507 1052 Bracket 1 -
507 1059 End stopper 2 -
507 1060 Terminal strip rail (1) 1 -
507 1061 Nut 5 -
507 1281 Screw 4 -
507 1640 Screw 1 -
NOTE! (1) L= 200 mm
DBAE577326-
Edition: D
Page: 2(2)
Updated: 23.09.2015
Terminal box
507 1063 507 1055

507 1054
507 1061
507 1053
Qty Wt.
507 1053 Damper 4 -

507 1061 Nut 5 -
DBAE577326-
Edition: A
Page: 1(1)
Updated: 26.05.2008
Speed sensors
SE 167
507 1325
507 1349
SE 168
Qty Wt.
507 1325 Bush 1 -

507 1349 Bush 1 -
DBAE577326-
DBAE577326-
Edition: B
Page: 1(1)
Updated: 13.03.2017
Pressure gauge valve
507 326
A
A
A-A
507 323 507 325
387 006 507 324 507 322
Qty Wt.
507 326 Pressure gauge valve 1 -

507 322 Screw 1 -
507 323 Valve 2 -
507 324 Distance ring 1 -
DBAE577326-
DBAE577326-
Edition: B
Page: 1(4)
Updated: 23.01.2012
Side cover lower part, A-side
507 100
A B
A B
507 074 507 077
Qty Wt.
507 074 Gasket 1 -

507 077 Gasket 1 -
507 100 Cover 1 -
DBAE577326-
Edition: B
Page: 2(4)
Updated: 23.01.2012
Section A - A
387 025
507 100 507 068
507 064
507 065
387 025
Qty Wt.
507 064 Screw * -

507 065 Washer * -
507 068 O-ring * -
507 100 Cover 1 -
NOTE! *) See page 4
DBAE577326-
Edition: B
Page: 3(4)
Updated: 23.01.2012
Section B - B
387 025
507 100 507 067
387 025
507 064
507 065
387 025
Qty Wt.

507 064 Screw * -
507 065 Washer * -
507 067 O-ring * -
507 100 Cover 1 -
NOTE! *) See page 4
DBAE577326-
Edition: B
Page: 4(4)
Updated: 23.01.2012

12V 16V 18V 20V
507 064 Screw 26 34 38 42
507 065 Washer 26 34 38 42
507 067 O-ring 12 16 18 20
507 068 O-ring 8 10 11 12
DBAE577326-
Edition: B
Page: 1(4)
Updated: 23.01.2012
Side cover lower part, B-side
507 059
A B
A B
507 077 507 074
Qty Wt.
507 059 Cover 1 -

507 074 Gasket 1 -
507 077 Gasket 1 -
DBAE577326-
Edition: B
Page: 2(4)
Updated: 23.01.2012
Section A - A
387 025
507 059 507 068
507 064
507 065
387 025
Qty Wt.
507 059 Cover 1 -

507 064 Screw * -
507 065 Washer * -
507 068 O-ring * -
NOTE! *) See page 4
DBAE577326-
Edition: B
Page: 3(4)
Updated: 23.01.2012
Section B - B
387 025
507 059 507 067
387 025
507 064
507 065
387 025
Qty Wt.

507 059 Cover 1 -
507 064 Screw * -
507 065 Washer * -
507 067 O-ring * -
NOTE! *) See page 4
DBAE577326-
Edition: B
Page: 4(4)
Updated: 23.01.2012

12V 16V 18V 20V
507 064 Screw 26 34 38 42
507 065 Washer 26 34 38 42
507 067 O-ring 12 16 18 20
507 068 O-ring 8 10 11 12
DBAE577326-
Edition: A
Page: 1(2)
Updated: 30.06.2010
Speed measuring system
507 314
507 315
507 1364
SE 180
507 542
SE 173-2
Qty Wt.
507 314 O-ring 2 -

507 315 Screw 2 -
507 542 Plug 1 -
SE173-2 Speed pick-up 1 -
DBAE577326-
Edition: A
Page: 2(2)
Updated: 30.06.2010
Speed measuring system
View A
507 539
507 540
507 541
SE 175
Qty Wt.
507 539 Screw 4 -

507 540 Bracket 1 -
507 541 O-ring 1 -
DBAE577326-
Edition: F
Page: 1(5)
Updated: 31.10.2016
Temperature measuring system for big end bearing
507 290
507 383
507 289
507 290
507 267
507 266
387 003
Qty Wt.
507 266 Temperature sensor 20 -

507 267 Antenna 20 0.3
507 289 Cable clip 96 -
507 290 Screw 44 -
DBAE577326-
Edition: F
Page: 2(5)
Updated: 31.10.2016
507 424 507 417 507 416
507 289
507 425 507 419 507 418 A
507 412
387 003 507 289
507 421
387 003
507 422
507 415
507 423
387 006
507 426 507 375
507 289 507 416
507 290
507 379 507 417
507 420 507 419 507 379
507 290 507 423 507 422 507 421

Qty Wt.
507 289 Cable clip 96 -

507 290 Screw 44 -
507 375 Cable (1) 1 0.2
507 379 Cable (1) 2 0.3
507 412 Screw 36 -
507 415 Cable gland 20 0.2
507 416 Cable (1) 2 0.3
507 417 Cable (1) 2 0.3
507 418 Cable (1) 1 0.3
507 419 Cable (1) 2 0.4
507 420 Cable (1) 1 0.4
507 421 Cable (1) 2 0.5
507 422 Cable (1) 2 0.5
507 423 Cable (1) 2 0.5
507 424 Cable (1) 1 0.4
507 425 Cable (1) 1 0.4
507 426 Cable (1) 1 0.6
DBAE577326-
Edition: F
Page: 3(5)
Updated: 31.10.2016
A
507 390 507 406
507 286 507 409 507 408
507 409
B
507 547
507 1470
507 548
507 1471
A C
507 411
507 285
C 507 386
507 414
507 387
507 407 507 388
507 410 507 389
Qty Wt.
507 285 Converter 2 4.0

507 286 Damper 8 -
507 386 Blocking plug 2 -
507 390 Screw 8 -
507 406 Bracket 2 2.3
507 407 Bracket 2 0.2
507 408 Washer 16 -
507 409 Nut 24 -
507 410 Screw 6 -
507 411 Cable tray (1) 1 1.6
507 547 Bracket 1 9.6
507 548 Screw 4 -
507 1471 Cable set 2 3.2
NOTE! (1) L= 500 mm
DBAE577326-
Edition: F
Page: 4(5)
Updated: 31.10.2016
A B C D
507 389
507 386 507 386
507 1470
507 388
507 387 507 387
507 387 507 387
Qty Wt.

DBAE577326-
Edition: F
Page: 5(5)
Updated: 31.10.2016
Length according to component size, related to number of cylinders
Part No. and Description Length in

millimeters
20V
507 375 Cable 3100
507 379 Cable 5200
507 416 Cable 3700
507 417 Cable 4300
507 418 Cable 4900
507 419 Cable 6100
507 420 Cable 6400
507 421 Cable 7000
507 422 Cable 7600
507 423 Cable 8200
507 424 Cable 5500
507 425 Cable 6700
507 426 Cable 8800
DBAE577326-
DBAE577326-
Edition: A
Page: 1(4)
Updated: 14.11.2011
Electrical equipment, A bank
504 128
PT 401 507 100 507 1375

PT 101
PT 401-2
PT 101-2
TE 101 507 194 507 167

TE 401 507 1351 507 168
Qty Wt.
504 128 Temperature sensor * 0.5

507 100 Cover 1 165
507 167 Cable set * -
507 168 Screw * -
507 194 Terminal box * 4.0
507 1351 Corrosion protection * -
507 1375 Cable * 7.2
TE101 Temperature sensor, 1 0.3
fuel, before engine
water, before engine
NOTE! (*) See page 4.
DBAE577326-
Edition: A
Page: 2(4)
Updated: 14.11.2011
504 128
507 194 507 167 507 1374

507 1351 507 168
Qty Wt.

507 167 Cable set * -
507 168 Screw * -
507 1374 Cable 2 5.4
DBAE577326-
Edition: A
Page: 3(4)
Updated: 14.11.2011
507 060 507 1193

507 062 507 1197
507 184
507 1199
507 1292 507 1292
507 1196
507 185
507 259
507 120
507 121 508 025
507 183 507 167 508 026
507 212 507 168
LS 108A
507 078
507 079
507 317
Qty Wt. Qty Wt.

507 060 Fixing piece * - NOTE! (*) See page 4.

507 062 Screw * -
507 078 Clamp * -
507 079 Screw * -
507 120 Damper * -
507 121 Nut * -
507 167 Cable set * -
507 168 Screw * -
507 183 Distance ring * -
507 184 Plug * -
507 212 Washer * -
507 1197 Plug * -
507 1199 Plug * -
507 1292 Blocking plug * -
508 025 Bracket 1 0.6
508 026 Screw 2 -
LS108A Level switch 1 0.5
DBAE577326-
Edition: A
Page: 4(4)
Updated: 14.11.2011

12V 16V 18V 20V
507 060 Fixing piece 12 16 20 20
507 062 Screw 24 32 40 40
507 078 Clamp 26 34 40 48
507 079 Screw 26 34 40 48
507 1193 Cable gland 20 24 26 28
507 1196 Cable gland 1 4 4 4
507 1197 Plug 46 64 62 60
507 1199 Plug 6 8 8 8
507 120 Damper 12 16 16 16
507 121 Nut 12 16 16 16
507 1292 Blocking plug 11 12 13 14
507 1351 Corrosion protection 3 4 4 4
507 1375 Cable - 1 1 1
507 167 Cable set 3 4 4 4
507 168 Screw 6 8 8 8
507 183 Distance ring 12 16 16 16
507 184 Plug 18 24 24 24
507 185 Cable gland 6 8 9 10
507 194 Terminal box 3 4 4 4
507 212 Washer 12 16 16 16
507 317 Steel strip 90 111 120 132
DBAE577326-
Edition: A
Page: 1(4)
Updated: 14.11.2011
Electrical equipment, B bank
504 128
507 059
507 1201
507 120
507 121
507 183
507 194 507 167 507 212
507 1351 507 168
Qty Wt.

507 059 Cover 1 165
507 120 Damper * -
507 121 Nut * -
507 167 Cable set * -
507 168 Screw * -
507 183 Distance ring * -
507 212 Washer * -
507 1201 Cable * 11.1
DBAE577326-
Edition: A
Page: 2(4)
Updated: 14.11.2011
504 128
507 1201
507 194 507 167 507 078

507 1351 507 168 507 079
507 317
Qty Wt.

507 078 Clamp * -
507 079 Screw * -
507 167 Cable set * -
507 168 Screw * -
507 1201 Cable * 11.1
DBAE577326-
Edition: A
Page: 3(4)
Updated: 14.11.2011
507 185 507 1193

507 1292 507 1197
507 060 507 184
507 062 507 1199

507 1292
507 1196
Qty Wt.
507 060 Fixing piece * -

507 062 Screw * -
507 184 Plug * -
507 1197 Plug * -
507 1199 Plug * -
507 1292 Blocking plug * -
DBAE577326-
Edition: A
Page: 4(4)
Updated: 14.11.2011

12V 16V 18V 20V
507 060 Fixing piece 12 16 20 20
507 062 Screw 24 32 40 40
507 078 Clamp 34 41 49 56
507 079 Screw 34 41 49 56
507 1193 Cable gland 8 10 10 12
507 1196 Cable gland 2 3 3 3
507 1197 Plug 33 56 56 54
507 1199 Plug 4 6 6 6
507 120 Damper 8 12 12 12
507 1201 Cable 2 3 3 3
507 121 Nut 8 12 12 12
507 1292 Blocking plug 8 11 12 13
507 1351 Corrosion protection 2 3 3 3
507 167 Cable set 2 3 3 3
507 168 Screw 4 6 6 6
507 183 Distance ring 8 12 12 12
507 184 Plug 13 19 19 19
507 185 Cable gland 6 8 9 10
507 194 Terminal box 2 3 3 3
507 212 Washer 8 12 12 12
507 317 Steel strip 66 81 97 120
DBAE577326-
Edition: A
Page: 1(2)
Updated: 19.04.2012
DBAE577326-
Edition: A
Page: 2(2)
Updated: 19.04.2012
Section A - A
507 404
507 405
387 002
507 402
Qty Wt.
507 402 O-ring 2 -

507 404 Bracket 1 -
507 405 Screw 2 -
DBAE577326-
Edition: A
Page: 1(1)
Updated: 28.08.2013
Adapter and test valve for pressure sensors
507 1521
507 1522 507 758
Qty Wt.

507 1522 Plug 1 -
DBAE577326-
DBAE577326-
Edition: A
Page: 1(1)
Updated: 25.04.2014
Pressure gauge valve
A A
A-A
507 1552 507 1551

507 1549
507 1553
507 1550
Qty Wt.
507 1549 Pressure gauge valve 1 0.5

507 1550 Screw 1 -
507 1553 O-ring 1 -
DBAE577326-
DBAE577326-
Edition: A
Page: 1(3)
Updated: 18.09.2014
Wiring harness assembly for lube oil module
507 366
507 367
507 1549
PT 201
507 1549
PT 201-2
A
507 234 507 234 TE 201 507 1549
507 1148 507 235 507 099
507 237 507 1146
Qty Wt.

507 234 Screw 11 -
507 235 Fastener 8 -
507 366 Screw 2 -
507 367 Bracket 1 1.0
NOTE! *) See 507-
DBAE577326-
Edition: A
Page: 2(3)
Updated: 18.09.2014
TE 482
507 099
507 1146
Qty Wt.

DBAE577326-
Edition: A
Page: 3(3)
Updated: 18.09.2014
507 230 B
507 1549
TE 601
507 099
507 365
PT 601
507 1549
507 236
507 237
507 1149
Qty Wt.

507 230 Boss 1 0.4
507 1149 Screw 6 -
TE601 Charge air temperature, 1 -
inlet
NOTE! *) See 507-
DBAE577326-
DBAE577326-
Edition: A
Page: 1(2)
Updated: 19.09.2014
Wiring harness for lube oil module
TE 601
PT 601
PT 201
PT 241
PT 201-2
TE 201
507 1520
TE 482
Qty Wt.
507 1520 Cable tie 28 -

PT241 Lube oil pressure, filter 1 0.8
inlet
TE601 Charge air temperature, 1 0.6
inlet
DBAE577326-
Edition: A
Page: 2(2)
Updated: 19.09.2014
Wiring harness for lube oil module
PT 201-2 507 173 PT 241

507 1520 507 1378 507 1520
TE 601
507 1520
507 1321
TE 482 PT 601 PT 201 TE 201

507 1520 507 1520 507 1520 507 1520
Qty Wt.
507 173 Terminal box 1 2.0

507 1520 Cable tie 28 -
PT241 Lube oil pressure, filter 1 0.8
inlet
TE601 Charge air temperature, 1 0.6
inlet
DBAE577326-
Edition: A
Page: 1(1)
Updated: 05.02.2016
Cable for converter, big end bearing temperature sensor system
507 1668 507 285 *
507 1668
Qty Wt.
507 285 Converter * 1 -

507 1668 Cable 8 -
NOTE! * Position of converter depends on

installation.
DBAE577326-
DBAE577326-
Edition: A
Page: 1(1)
Updated: 30.08.2011
Oil level transducer
508 043
508 005
508 005
508 006
LS 204
508 002
508 009
508 049
508 019
387 006
Qty Wt.

508 002 Screw 2 -
508 006 Screw 2 -
508 009 Nut 2 -
508 019 Bracket 1 -
508 043 Bush seal 1 -
508 049 Washer 2 -
LS204 Level switch, oil level 1 0.5
DBAE577326-
DBAE577326-
Edition: B
Page: 1(1)
Updated: 05.09.2011
Pressure gauge
514 024
514 003 514 025
514 008
514 004
514 007
514 026
514 009
514 030
514 009
514 029
514 013
514 009
514 010
514 020
514 021
514 014
514 013
Qty Wt.
514 003 Bracket 1 0.5

514 007 Clamp 4 -
514 008 Screw 2 -
514 009 Clamp 26 -
514 010 Screw 4 -
514 014 Pipe 1 0.2
514 020 Pipe 1 0.2
514 021 Pipe 1 0.2
514 024 Pipe union 3 0.1
514 025 Coupling 3 0.1
514 026 Screw 2 0.1
514 029 Screw 3 -
514 030 Screw 3 -
DBAE577326-
DBAE577326-
Edition: A
Page: 1(4)
Updated: 06.08.2013
Connecting box
516 500
516 499
516 391
516 521 A
516 678
516 717
516 020
Qty Wt.

516 391 Push button 1 0.1
516 499 Display unit 1 2.0
516 500 Display unit 1 2.0
516 521 Guard 1 -
516 678 Corrosion protection 1 0.3
516 717 Box for connecting box 1 35.0
DBAE577326-
Edition: A
Page: 2(4)
Updated: 06.08.2013
Connecting box
516 519 516 220 516 125 516 495 516 128 516 718
516 220
516 683 516 502 516 496 516 724 516 719
516 501
516 823 516 497 516 823
516 502
516 720
516 503
516 721
516 387
516 722
516 672
516 723
516 673
516 501 516 912
516 502 516 520
516 912 516 683
516 823
516 681 516 709
516 823 516 520
516 519 516 520 516 220 516 683
516 683 516 683 516 292 516 498 516 501 516 823
516 823 516 823 516 823 516 562 516 502
Qty Wt. Qty Wt.
516 125 Relay 7 - 516 720 Terminal strip 2 -

516 128 End plate 1 - 516 721 Terminal strip 2 -
516 220 Terminal strip 25 - 516 722 Terminal strip 2 -
516 292 Control unit 1 1.8 516 723 End plate 1 -
516 387 Engine safety module 1 2.1 516 724 Jumper 1 -
516 495 Power distribution 1 1.4 516 823 Screw 58 -
module 516 912 Connector set for ESM 1 0.1
516 496 Plug 6-pin 2 -
516 497 Plug 12-pin 2 -
516 498 Plug 8-pin 17 -
516 502 End plate 7 -
516 503 End clamp 13 -
516 519 Cable tray 1 0.1
516 520 Cable tray 3 0.1
516 562 Plug 8-pin, double wire 2 -
entry
516 672 Resistor 470 R 2 -
516 673 Resistor 22 kR 4 -
516 681 Terminal strip rail 1 0.2
516 683 Holder for tie wrap 30 -
516 709 Screw 4 -
DBAE577326-
Edition: A
Page: 3(4)
Updated: 06.08.2013
Connecting box
516 516
516 515
516 649
516 618
516 516 516 512

516 649 516 516
516 493
516 494
516 624
B
Qty Wt.
516 493 Damper 6 -

516 494 Nut 6 -
516 515 Nut 4 -
516 516 Nut 10 -
516 624 Washer 6 -
DBAE577326-
Edition: A
Page: 4(4)
Updated: 06.08.2013
Connecting box
516 512
516 614
516 516
516 697
516 510
516 512
516 514
516 516
516 509
516 513 516 509
516 510 516 513
516 514 516 510
516 514
Qty Wt.

516 513 Nut 17 -
516 514 Nut 8 -
516 516 Nut 10 -
516 697 Screw 1 -
DBAE577326-
Edition: A
Page: 1(2)
Updated: 09.08.2013
Wiring harness assembly for connecting box
516 808 516 615 107 761

516 020
516 809 516 809 107 778
516 898
516 899
PTZ 201
516 809
PT 311
516 809
107 622
PT 601-4
PT 311-2
516 809 516 804 516 803
516 809
PT 601-2 516 809 516 1054
PT 301-2 516 809 516 826 GS 171

PT 301 516 809
516 809 516 828
516 809
LS 108B 516 831
508 025 516 898
516 615 516 809 516 808 GS 792 516 615
516 809 516 809 516 809 516 809
Qty Wt. Qty Wt.

107 622 Cover 1 13.7 PT601-2 Pressure sensor 1 -

107 761 Bracket 1 1.6 PT601-4 Pressure sensor 1 -
107 778 Screw 2 - PTZ201 Pressure sensor 1 0.8
508 025 Bracket 1 0.6
516 020 Connecting box 1 80.0
516 615 Cable 1 0.4
516 803 Nut 1 -
516 804 Cable set 1 0.7
516 808 Cable tray 2 1.6
516 831 Screw 1 -
516 898 Washer 5 -
516 899 Screw 4 -
DBAE577326-
Edition: A
Page: 2(2)
Updated: 09.08.2013
Wiring harness assembly for connecting box
516 652
516 809
516 694 516 694
516 809 516 809
Qty Wt.
516 652 Cable set 2 -

516 694 Cable set 4 5.5
DBAE577326-
Edition: B
Page: 1(3)
Updated: 02.01.2017
Electrical equipment
A
PTZ 201
516 900 516 1053
516 901
PT 311
516 1053
PT 311-2
516 1053
CV 161 516 799

516 800
516 902
GS 792
Qty Wt.
516 799 Fastener 17 -

516 800 Screw 17 -
516 901 Nut 1 -
516 1053 Screw 14 -
CV161 Solenoid valve, actuator 1 -
control
PTZ201 Pressure sensor 1 0.7
DBAE577326-
Edition: B
Page: 2(3)
Updated: 02.01.2017
PT 601-2
PT 601-4
507 326
516 1053
PT 301-2
PTZ 201 516 1053
516 1053 507 1549
PT 301
516 1053
507 1549
516 799 LS 108B

516 800 508 026
516 902
Qty Wt.
507 326 Pressure gauge valve * 1 0.2

507 1549 Pressure gauge valve * 2 0.5
508 026 Screw 2 -
516 799 Fastener 17 -
516 800 Screw 17 -
516 1053 Screw 14 -
PTZ201 Pressure sensor 1 0.7
NOTE! *) See 507-
DBAE577326-
Edition: B
Page: 3(3)
Updated: 02.01.2017
GS 171
Qty Wt.
DBAE577326-
DBAE577326-
Edition: E
Page: 1(5)
Updated: 09.01.2017
Accessories for common base frame
604 513
604 1015
604 512
604 513
604 509
604 516
604 285
604 638
604 513
604 516
604 513
604 851 604 081
604 216
604 285
604 638
604 516
604 082
604 285
604 513
604 516
Qty Wt.
604 081 Pipe 1 33.2

604 082 Pipe 1 27.2
604 216 Bracket 1 3.0
604 285 Screw 24 -
604 509 Pipe 1 33.7
604 512 Nut 4 -
604 513 O-ring 7 -
604 516 Washer 58 -
604 638 Screw 10 0.1
604 851 Pipe 1 12.0
604 1015 Pipe 1 18.7
DBAE577326-
Edition: E
Page: 2(5)
Updated: 09.01.2017
604 285
387 025
604 516
Y 604 516 604 858
604 638 604 884
604 115 604 800
604 516
604 263 604 944
604 686
604 512 604 1216
604 111
604 516 604 263
604 118
604 528 604 512
604 510
604 853
604 276 604 511
604 823 604 512
604 115
604 086 604 217
604 521 604 884
604 652 604 522 604 944

X
604 884
Qty Wt. Qty Wt.
604 086 Nut 18 - 604 1216 Screw 8 -

604 118 Valve 1 7.2
604 510 Gasket 1 -
604 511 Screw 4 0.1
604 512 Nut 4 -
604 115 Screw 4 -
604 217 Screw 2 -
604 263 Screw 10 0.1
604 276 Pipe 1 11.0
604 285 Screw 24 -
604 516 Washer 58 -
604 521 Screw 18 -
604 522 Clamp 1 1.3
604 528 O-ring 1 -
604 638 Screw 10 0.1
604 652 Screw 4 -
604 686 Screw 4 0.2
604 800 Pipe clamp 2 9.2
604 853 Gasket 1 -
604 858 Support 1 28.0
604 884 Washer 40 -
604 944 Clamp 2 4.0
DBAE577326-
Edition: E
Page: 3(5)
Updated: 09.01.2017
604 515
604 516
604 852
604 285
604 513
604 116
604 516
604 117
604 855
604 518
604 091
604 519
604 118
604 512
604 517
604 514
604 1338
604 1551
Qty Wt.
604 091 Pipe 2 14.0

604 118 Valve 1 7.2
604 512 Nut 4 -
604 514 O-ring 2 -
604 1338 Washer 8 -
604 1551 Screw 4 0.1
604 116 Washer 8 -
604 117 Screw 8 -
604 285 Screw 24 -
604 513 O-ring 7 -
604 515 Screw 4 -
604 516 Washer 58 -
604 517 Plate 1 167
604 518 Screw 10 0.4
604 519 Washer 10 -
604 852 Water pipe 1 10.5
604 855 Pipe 1 43.4
DBAE577326-
Edition: E
Page: 4(5)
Updated: 09.01.2017
604 086
X
604 520
604 521
604 884
604 1216
604 086
604 521
604 884
604 063
604 743
604 086
604 521
604 884
Qty Wt.
604 063 Bracket 3 -

604 086 Nut 18 -
604 520 Clamp 3 -
604 521 Screw 18 -
604 743 Bracket 1 -
604 884 Washer 40 -
604 1216 Screw 8 -
DBAE577326-
Edition: E
Page: 5(5)
Updated: 09.01.2017
604 285
604 516
604 262
604 263 604 516
604 516 604 686

604 800
604 516
604 512
604 638
Qty Wt.
604 262 Bracket 1 7.2

604 263 Screw 10 0.1
604 285 Screw 24 -
604 512 Nut 4 -
604 516 Washer 58 -
604 638 Screw 10 0.1
604 686 Screw 4 0.2
604 800 Pipe clamp 2 9.2
DBAE577326-
DBAE577326-
Edition: C
Page: 1(2)
Updated: 11.02.2014
Tools for cylinder liner
800 123 800 103
800 007
800 009
Qty Wt.
800 007 Lifting tool for cylinder 1 23.0

liner
800 009 Dismantling tool for 1 1.5
antipolishing ring
800 103 Assembly tool for piston 1 6.3
800 123 Fastening tool for 4 0.4
cylinder liner
DBAE577326-
Edition: C
Page: 2(2)
Updated: 11.02.2014
Tools for cylinder liner
800 253
800 254
800 008
Qty Wt.
800 008 Honing equipment 1 35.0

800 253 Honing stone 8 -
800 254 Honing stone 16 -
DBAE577326-
Edition: B
Page: 1(1)
Updated: 11.02.2014
Tools for main bearings
800 005 800 004
Qty Wt.
800 004 Turning tool for main 1 0.2

bearing shell
800 005 Turning tool for main 1 1.2
bearing shell
DBAE577326-
DBAE577326-
Edition: B
Page: 1(2)
Updated: 12.02.2014
Tools for piston
800 002 800 106 800 011
800 001
802 000
Qty Wt.
800 001 Piston ring pliers 1 0.6

800 002 Pliers for securing ring 1 1.5
802 000 Tap M12 1 -
800 011 Spare tips for pliers 1 -
800002, 90 degrees
800 106 Spare tips for pliers 1 -
800002, straight
DBAE577326-
Edition: B
Page: 2(2)
Updated: 12.02.2014
Tools for piston
800 013
800 012
Qty Wt.
800 012 Lifting tool for piston 1 5.8

800 013 Clamp tool for piston 1 9.9
rings
DBAE577326-
Edition: B
Page: 1(2)
Updated: 12.02.2014
Tools for connecting rod
800 101
800 102
800 016
800 099
800 100
800 098
800 108
Qty Wt.
800 016 Assembly rail, complete 1 23.7

800 098 Assembly rail 1 -
800 099 Support 1 -
800 100 Mounting sledge 1 -
800 101 Mounting sledge 1 -
800 102 Mounting support 1 -
800 108 Support 1 -
DBAE577326-
Edition: B
Page: 2(2)
Updated: 12.02.2014
Tools for connecting rod
800 107 800 018
Qty Wt.
800 018 Limiter, to be used with 1 1.0

800168
800 107 Tool 1 0.9
DBAE577326-
Edition: F
Page: 1(5)
Updated: 12.02.2014
Hydraulic tightening tools
800 021 800 022 800 020
Qty Wt.
800 020 Hydraulic tools M27*2, 2 10.4

including 800097
800 021 Stud remover M27*2 1 0.5
800 022 Pin for tightening of nuts 1 0.1
M27*2
DBAE577326-
Edition: F
Page: 2(5)
Updated: 12.02.2014
A-A
B 800 087 800 255
800 088 800 256
A 800 085 800 210
A B 800 086
800 080 800 083

800 081 800 084
800 193
800 082
387 029
800 097
800 157
800 020
Qty Wt.
800 020 Hydraulic tools M27*2, 1 10.4

including 800097
800 082 O-ring 6 -
800 083 O-ring 6 -
800 086 O-ring 2 -
800 087 O-ring 2 -
800 097 Distance sleeve M27*2 1 2.0
800 157 Screw for M27 2 1.1
hydraulic tightening
tool
800 193 Quick coupling, male 2 -
800 255 Nut 2 -
DBAE577326-
Edition: F
Page: 3(5)
Updated: 12.02.2014
B-B
800 089
Qty Wt.
800 089 O-ring 3 -
DBAE577326-
Edition: F
Page: 4(5)
Updated: 12.02.2014
800 157
800 255
800 257
800 256
800 210
Qty Wt.
800 257 Spare parts kit for 1 4.8

hydraulic tightening tool
800 157 Screw for M27 2 1.1
hydraulic tightening
tool
800 255 Nut 2 -
DBAE577326-
Edition: F
Page: 5(5)
Updated: 12.02.2014
800 264
800 081 800 085
800 082 800 086
800 083 800 087
800 084 800 089 800 088
Qty Wt.
800 264 Sealing set for hydraulic 1 -

tightening tool
800 082 O-ring 6 -
800 083 O-ring 6 -
800 086 O-ring 2 -
800 087 O-ring 2 -
800 089 O-ring 3 -
DBAE577326-
DBAE577326-
Edition: B
Page: 1(2)
Updated: 12.02.2014
Tools for cylinder head
800 029
800 075
800 174
800 126
800 031
800 030
800 028
Qty Wt.
800 028 Grinding tool for valves 1 1.7

800 029 Removing tool for 1 4.8
injection and starting
valve
800 030 Valve clearance feeler 1 -
gauge
800 031 T-wrench for indicator 1 0.5
valve
800 075 Cleaning tool for 1 3.1
injection valve sealing
surface
800 174 Cleaning felt 1 -
800 126 Extractor tool for valve 1 4.5
guide
DBAE577326-
Edition: B
Page: 2(2)
Updated: 12.02.2014
Tools for cylinder head
800 027 800 026
Qty Wt.
800 026 Lifting tool for cylinder 1 10.1

head
800 027 Mounting and 1 9.5
dismantling tool for
valves
DBAE577326-
Edition: B
Page: 1(1)
Updated: 12.02.2014
Tools for intermediate gear
800 024
Qty Wt.
800 024 Extractor plate 1 4.5
DBAE577326-
DBAE577326-
Edition: D
Page: 1(7)
Updated: 18.04.2012
Tools for injection equipment
800 073 800 033 800 140
800 271
800 272
800 038
Qty Wt.
800 033 Dismantling tool for 1 3.4

injection pump spring
800 038 Limiter for fuel rack 1 0.2
movements
800 073 Lifting tool for injection 1 3.8
pump
800 140 Extractor tool for 1 1.8
injection tappet *
800 271 Digital depth gauge with 1 1.0
data output, 150 mm
800 272 Single extension base, 1 0.5
180 mm
DBAE577326-
Edition: D
Page: 2(7)
Updated: 18.04.2012
800 184 800 179 800 177 800 181
800 178 800 180
800 183 800 182
800 039
Qty Wt.
800 039 Moving tool for fuel pipe 1 5.3

sleeves
800 177 Saddle 1 0.5
800 178 Saddle 1 0.5
800 179 Lever 1 2.4
800 180 Limiter 1 0.2
800 181 Limiter 1 0.3
800 182 Limiter 1 0.1
800 183 Support 1 0.8
800 184 Extension bar 1 0.9
DBAE577326-
Edition: D
Page: 3(7)
Updated: 18.04.2012
800 127
800 037 800 035 800 036
Qty Wt.
800 035 Socket wrench 36mm 1 0.2

800 036 Flare nut wrench for 1 0.3
tightening of injection
pipes
800 037 Socket wrench 55 mm 1 1.8
for nozzle cap nut
800 127 Tool for connection 1 0.6
piece, flange screw
DBAE577326-
Edition: D
Page: 4(7)
Updated: 18.04.2012
800 034
864 047
800 262
864 042 864 043
864 045
864 039 864 040

864 044
864 041 864 046
Qty Wt.
800 034 Testing tool for injection 1 17.0

valve (*)
800 262 Holder 1 6.0
864 047 Adapter 1 0.5
864 039 Hose 1 1.0
864 040 Injection chamber 1 1.0
864 041 Tank 1 1.0
864 042 Cap 1 0.5
864 043 Pressure gauge 1 1.0
864 044 Valve 1 3.0
864 045 Pressure control valve 1 2.0
864 046 High pressure pump 1 4.0
NOTE! (*) For available seal kit, see page 5

and 6.
NOTE! (*) Tool requires regular calibration.
DBAE577326-
Edition: D
Page: 5(7)
Updated: 18.04.2012
864 134
864 133
864 135 864 136 864 137
Qty Wt.
864 119 Seal kit for injection 1 -

valve testing tool
864 133 Seat (1) 2 -
864 134 Ball (1) 2 -
864 135 Spring (1) 2 -
864 136 Spring (1) 2 -
864 137 O-ring (1) 1 -
NOTE! (1) Parts included in the kit not

available separately!
DBAE577326-
Edition: D
Page: 6(7)
Updated: 18.04.2012
864 126
864 121 864 127 864 126
864 124
864 123
864 125 864 129
864 128
864 120 864 122

864 126 864 238
864 130
864 131 864 236
864 235
864 132 864 234
864 233
Qty Wt.
864 119 Seal kit for injection 1 -

valve testing tool
864 120 O-ring (1) 1 -
864 121 O-ring (1) 1 -
864 122 O-ring (1) 1 -
864 123 O-ring (1) 1 -
864 124 Spring (1) 1 -
864 125 O-ring (1) 3 -
864 126 O-ring (1) 3 -
864 127 O-ring (1) 1 -
864 128 O-ring (1) 1 -
864 129 O-ring (1) 1 -
864 130 Support ring (1) 1 -
864 131 Back-up ring (1) 1 -
864 132 Seal (1) 1 -
864 233 Seal (1) 2 -
864 234 Ball (1) 2 -
864 235 Spring (1) 2 -
864 236 Spring (1) 2 -
864 238 O-ring (1) 1 -
NOTE! (1) Parts included in the kit not

available separately!
DBAE577326-
Edition: D
Page: 7(7)
Updated: 18.04.2012
864 203 864 204 864 205

864 200
864 209
864 201
864 202 864 206
864 207
864 208
Qty Wt.
864 200 Oil mist separator (1) 1 4.0

864 201 Valve 1 0.2
864 202 Pressure regulator 1 1.0
864 203 Manometer 1 0.1
864 204 Manifold 1 0.5
864 205 Manometer 1 0.1
864 206 Air filter 1 0.3
864 207 Filter element 1 0.1
864 208 Nipple 1 -
864 209 Quick coupling 1 -
NOTE! (1) Used with testing tool for injection

valve.
NOTE! (2) Not included in testing tool for
injection valve.
DBAE577326-
DBAE577326-
Edition: E
Page: 1(1)
Updated: 24.09.2013
Tools for turbocharger
800 312
Qty Wt.
800 312 Tools for turbocharger *) 1 -
NOTE! *) State engine number,

turbocharger type and serial
number/Ht number when ordering.
DBAE577326-
DBAE577326-
Edition: C
Page: 1(4)
Updated: 04.05.2010
Hydraulic tool (M56)
800 048
800 049 800 046 800 047

800 045
800 050
Qty Wt.
800 045 Hydraulic tools 1 -

800 046 Hydraulic tools M56, 2 18.2
including 800095
including 800096
800 048 Stud remover M56 1 1.2
800 049 Pin for tightening of 1 -
nuts M56
800 050 Lifting tool for hydraulic 1 14.0
cylinders M56
DBAE577326-
Edition: C
Page: 2(4)
Updated: 04.05.2010
861 004 861 003
861 061 861 060

387 029 387 029 800 095
861 101
387 004
800 046
387 029
Qty Wt.

including 800095
800 095 Distance sleeve M56 1 -
861 003 O-ring 1 -
861 004 O-ring 1 -
DBAE577326-
Edition: C
Page: 3(4)
Updated: 04.05.2010
800 047
861 101
387 020 861 064 800 096
861 003
861 004 861 062
387 029 861 063 387 029
387 029
Qty Wt.

including 800096
800 096 Distance sleeve M56 1 13.0
861 003 O-ring 1 -
861 004 O-ring 1 -
861 064 Pin 1 -
DBAE577326-
Edition: C
Page: 4(4)
Updated: 04.05.2010
800 051
Qty Wt.
800 051 Lifting tool for hydraulic 1 -

cylinder M56
DBAE577326-
Edition: D
Page: 1(3)
Updated: 05.06.2015
800 041
861 201 800 044
800 040
800 043 800 042
861 055
Qty Wt.
800 040 Hydraulic tools 1 -

800 041 Hydraulic cylinder M42 2 5.5
800 042 Distance sleeve M42 2 2.2
800 043 Pin for tightening of 1 -
nuts M42
800 044 Stud remover M42 1 1.1
861 055 Distance sleeve for big 2 1.1
counterweight
mounting
861 201 Swivel coupling 2 0.3
DBAE577326-
Edition: D
Page: 2(3)
Updated: 05.06.2015
861 101 861 024

861 218 861 026
861 023
861 025
800 041
Qty Wt.
800 041 Hydraulic cylinder M42 1 5.5

861 023 O-ring 1 -
861 024 O-ring 1 -
DBAE577326-
Edition: D
Page: 3(3)
Updated: 05.06.2015
800 051
Qty Wt.
800 051 Lifting tool for hydraulic 1 -

cylinder
DBAE577326-
DBAE577326-
Edition: B
Page: 1(2)
Updated: 12.02.2014
800 114
800 113 800 115
800 112
800 117
800 125
Qty Wt.
800 115 Hydraulic tightening tool, 1 90.0

complete
800 112 Hydraulic tool, 1 61.8
including 800147
800 113 Support for hydraulic 1 3.6
tool 800112
800 114 Mounting and removing 1 1.2
tool
800 117 Lifting device for 1 5.8
hydraulic tool
800 125 Fastening arm for 1 0.5
hydraulic tool 800112
DBAE577326-
Edition: B
Page: 2(2)
Updated: 12.02.2014
800 147
861 101
800 154
800 155 800 112
800 152
800 153
Qty Wt.
800 112 Hydraulic tool, including 1 61.8

800147
800 147 Distance sleeve M80 1 -
for intermediate gears
800 152 O-ring 1 -
800 154 O-ring 1 -
DBAE577326-
Edition: B
Page: 1(2)
Updated: 10.12.2009
High pressure pump
860 150 861 101
861 101
800 053
800 056
800 200
Qty Wt.
800 053 High pressure pump 1 13.9

(1000 bar)
800 243 Repair kit for high 1 -
pressure pump
860 150 Manometer 1 -
800 056 Flexible hose 3000 mm, 1 1.1
including quick
couplings
800 200 Flexible hose 1000 mm, 1 0.9
including quick
couplings
DBAE577326-
Edition: B
Page: 2(2)
Updated: 10.12.2009
High pressure pump
861 148
800 056
861 193 861 192
861 196
800 200
861 194 861 194
Qty Wt.
800 056 Flexible hose 3000 mm, 2 1.1

including quick
couplings
861 148 Flexible hose 3000 mm 1 -
800 200 Flexible hose 1000 mm, 3 0.9
including quick
couplings
861 196 Flexible hose 780 mm 1 -
DBAE577326-
Edition: E
Page: 1(5)
Updated: 24.10.2013
Miscellaneous tools
837 055
800 062 800 074
837 077
837 063
800 063
800 122
800 176
Qty Wt.
800 062 Mounting and removing 1 24.8

tool for camshaft bearing
bu
800 063 Hydraulic extractor 1 11.5
800 074 Wrench for centrifugal 1 0.8
filter
800 122 Extractor plate for holder 1 0.4
of thermostatic element
800 176 O-ring 2 -
837 055 Extractor for impeller of 1 0.4
water pump
837 063 O-ring 2 -
837 077 O-ring 2 -
DBAE577326-
Edition: E
Page: 2(5)
Updated: 24.10.2013
Miscellaneous tools
848 026 848 021 800 066 800 067
387 006 387 006
800 064 848 024
848 034
848 029
848 035
848 028
848 036 800 141
387 006
806 032
848 025
800 068 800 069
800 283
Qty Wt.
800 064 Checking tool for 1 1.2

cylinder/valves tightness
848 021 Manometer 1 0.2
848 024 Adapter 1 -
848 025 O-ring 1 -
848 028 Ball valve 1 -
848 029 Hose adapter 1 -
848 035 Nut 1 -
848 036 Bush 1 -
800 066 Locking plate for 8 0.2
injection pump tappet
800 067 Securing pin for valve 16 -
tappet
800 068 Lifting eye bolt M12 1 0.2
800 069 Lifting eye bolt M16 1 0.3
800 141 Tool for cylinder liner 1 0.1
temperatur sensor
800 283 Box wrench head 21 1 0.1
mm
806 032 Bit, hexagon socket 1 0.3
screw 17 with 3/4"
square driv
DBAE577326-
Edition: E
Page: 3(5)
Updated: 24.10.2013
Miscellaneous tools
800 065
Qty Wt.
800 065 Deflection indicator, 1 4.3

crankshaft. D1-4.
DBAE577326-
Edition: E
Page: 4(5)
Updated: 24.10.2013
Miscellaneous tools
800 063
861 101
387 004
834 005
834 006
834 007
834 009
834 008
Qty Wt.
800 063 Hydraulic extractor 1 11.5

834 006 O-ring 1 -
834 007 Snap ring 1 -
834 008 O-ring 1 -
834 009 O-ring 1 -
DBAE577326-
Edition: E
Page: 5(5)
Updated: 24.10.2013
Miscellaneous tools
846 222
Qty Wt.
846 222 Mounting tool for charge 1 161

air cooler
DBAE577326-
DBAE577326-
Edition: A
Page: 1(1)
Updated: 20.06.2011
Low pressure handpump
800 059
800 058
800 289
Qty Wt.
800 058 Low pressure pump 1 -

(150 bar)
800 059 Low pressure pump 1 -
(150 bar)
DBAE577326-
DBAE577326-
Wärtsilä is a global leader in complete lifecycle power solutions for the marine and energy markets.
By emphasising technological innovation and total efficiency, Wärtsilä maximises the environmental
and economic performance of the vessels and power plants of its customers. Wärtsilä is listed on the
NASDAQ OMX Helsinki, Finland.
See also www.wartsila.com
WÄRTSILÄ® is a registered trademark. © 2017 Wärtsilä Corporation.
Wärtsilä Services Main Office Vaasa, Finland

Switchboard +358 10 709 0000
Find local offices at www.wartsila.com/contact

Paae 229540 SPC en

Uploaded by

Copyright:

Available Formats

Paae 229540 SPC en

Uploaded by

Document Information

Original Title

Copyright

Available Formats

Share this document

Share or Embed Document

Sharing Options

Did you find this document useful?

Is this content inappropriate?

Copyright:

Available Formats

Paae 229540 SPC en

Uploaded by

Copyright:

Available Formats

What does the document discuss?

What does the document discuss?

What parts are included in the catalog?

What parts are included in the catalog?

Engine Spare Parts Catalogue

Date of issue 14.09.2017

Product type W20V32GD

Product number PAAE229540

Product type W20V32

Product number: PAAE229540

100 Engine block, bearings, oil sump

107-0234B Covers between cylinder heads

110 Crankshaft, flywheel

120 Cylinder head with valves

125-0002C Indicator valve

130 Intermediate gears

140 Valve mechanism, camshaft

150 Charge air system

160 Injection equipment

180 Lubricating oil pumps, thermostatic valves

190 Cooling water pumps, thermostatic valves

200 Exhaust manifold

210 Starting equipment

220 Regulating mechanism

354-0014F LT-water pipes in flywheel end

370 Cleaning device

450 Pneumatic components

474-0023C Lube oil module

480 Turning device

500 Transducers, instrument panel, thermometers

507-0360A Temperature measuring system for big end bearing

600 Connecting pieces, extension shaft, electrical motors

Product type W20V32

Air block 218-0013C

Bearing cover for camshaft B-bank 131-0006D

Cylinder liner with anti-polishing ring 100-0021E

Cover plate for cylinderhead cover 107-0213A

Centrifugal filter 473-0005B

Drain pipe from receiver 156-0106A

Engine block 100-0063A

Fuel pipes in free end 350-0067C

Grounding equipment 100-0035C

Hydraulic jack for main bearing cap 100-0007F

Inlet valve with rotocap 121-0003B

Lifter for injection pump 161-0002D

Multi cover B-bank 107-0276B

Oil strainer for suction pump 100-013A

Overspeed trip device 228-0016B

Pump cover 107-0190E

Rocker arms and bearing bracket 143-003A

Side covers, lower part 20V32 107-0161B

Speed pickup for TC 156-019B

Tools for injection equipment 816-0004D

Vibration damper 110-0004F

Wet sump 100-0054A

1. Wärtsilä spare parts

This page has intentionally been left blank.

2. Ordering spare parts

2.1 Where to order