CD Micro System MCM302

TABLE OF CONTENTS

Location of PC Boards ............................................. 1-1 Power Board.................................................................. 7

Electronic Specification ............................................. 1-2 Circuit diagram ...................................................... 7-1
Measurement Setup ................................................ 1-3 Layout diagram ...................................................... 7-2
Service Aids............................................................... 1-4 Exploded View .......................................................... 8-1
Software Version Check & Upgrade ........................ 2-1 Service Partlist ......................................................... 9-1
Malfuction Check Chart ............................................. 2-2 Factory Partlist ...................................................... 10-1
Disassembly Diagram................................................ 3-1
Block Diagram ......................................................... 4-1
Wiring Diagram ......................................................... 4-2
Display Board ............................................................... 5
Circuit diagram ...................................................... 5-1
Layout diagram ...................................................... 5-2
Decoder Board ............................................................ 6
Circuit diagram ............................................. 6-1 to 6-3
Layout diagram ...................................................... 6-4

2009

DB 0907 3141 785 33420

Version 1.0
 1-1

Location of PC Boards

Display Board Decoder Board Power Board

VERSION VARIATIONS :
Type /Versions: MCM302

Service policy /05 /12 /37 /55 /58 /61 /79 /93 /94 /96 /98
Board in used:
LCD DISPLAY BOARD C C
CD DECODER BOARD M M
POWER BOARD M M

Type /Versions: MCM302

Features Feature diffrence /05 /12 /37 /55 /58 /61 /79 /93 /94 /96 /98
RDS
VOLTAGE SELECTOR
ECO STANDBY - DARK
TDS
* TIPS : C -- Component Level Repair.
M -- Module Level Repair
-- Used
 1-2

Electronic Specification

AMPLIFIER SPEAKERS
Rated Output Power .........................25W x 2RMS Speaker Impedance ................................................ 4ohm
Signal-to-noise ratio ...................................≥65dBA Speaker Driver, base ................................................4"
Frequency response............. 60Hz~20KHz ±3.0db Speaker Driver, tweeter ............................................NA
Aux Input .................................0.5V RMS 20k ohm Frequency Response
e ......................60Hz~20kHz ±3.0db

DISC GENERAL INFORMATION

Laser Type .......................................Semiconductor Total Output power ....................................... 5 0 W R M S
Disc Diameter .........................................12cm/8cm AC Power ..................................................... 230 V / 50Hz
Support Disc ........................................................... Operation Power Consumption ................................. 25W
CD-DA,CD-R,CD-RW,MP3 Standby Power Consumption ...................................
. <4W
Audio DAC ......................................24Bits/44.1kHz Eco Standby Power Consumption .............................<1W
Total Harmonic Distortion .................＜0.1%(1kHz) Headphone Output .................................2X15mV 32ohm
Frequency Response .........................20Hz~20kHz USB Direct ......................................................Version 1.1
Signal to Noise Ratio .................................≥65dBA Dimensions
– Main unit (w x h x d) ............................200x115x250mm
TUNER – Speaker box (w x h x d) .......................150x250x165mm
– SUBwoofer(w x h x d) ...............................................NA
FM Tuning Range .............................87.5~108MHz
Weight
Tuning grid ...........................................100k/50kHz
– With Packing ...................................................6.75KG
Sensitivity – Main Unit ...........................................................2.55KG
- Mono, 26db S/N Ratio ....................................5uV – Speaker box ....................................................2X1.7KG
– Stereo, 50dB S/N Ratio ...............................100uV – SUBwoofer................................................................NA
Selectivity .......................................................>33dB
Image Rejection ............................................>25dB Specifications and external appearance are
Total Harmonic Distortion ...................................3% subject to change without notice.
Signal to Noise Ration ................................≥65dBA
 1-3

MEASUREMENT SETUP

Tuner FM

Bandpass
DUT 250Hz-15kHz LF Voltmeter
e.g. 7122 707 48001 e.g. PM2534
RF Generator
e.g. PM5326
Ri=50:

S/N and distortion meter

e.g. Sound Technology ST1700B

Use a bandpass filter to eliminate hum (50Hz, 100Hz) and disturbance from the pilottone (19kHz, 38kHz).

Tuner AM (MW,LW)
Bandpass
250Hz-15kHz LF Voltmeter
DUT e.g. 7122 707 48001 e.g. PM2534

RF Generator
e.g. PM5326
S/N and distortion meter
e.g. Sound Technology ST1700B
Ri=50:

Frame aerial
e.g. 7122 707 89001

To avoid atmospheric interference all AM-measurements have to be carried out in a Faraday´s cage.
Use a bandpass filter (or at least a high pass filter with 250Hz) to eliminate hum (50Hz, 100Hz).

CD Recorder
Use Audio Signal Disc SBC429 4822 397 30184 Use Universal Test Cassette CrO2 SBC419 4822 397 30069
(replaces test disc 3) or Universal Test Cassette Fe SBC420 4822 397 30071

DUT
DUT LF Generator L
L e.g. PM5110

R
R
S/N and distortion mete
S/N and distortion meter e.g. Sound Technology ST170
e.g. Sound Technology ST1700B

LEVEL METER
LEVEL METER e.g. Sennheiser UPM550
e.g. Sennheiser UPM550 with FF-filter
with FF-filter
 1-4

SERVICE AIDS

GB WARNING ESD
All ICs and many other semi-conductors are
susceptible to electrostatic discharges (ESD).
Careless handling during repair can reduce life
drastically.
When repairing, make sure that you are
connected with the same potential as the mass
of the set via a wrist wrap with resistance.
Keep components and tools also at this
potential.

GB
Safety regulations require that the set be restored to its original CLASS 1
condition and that parts which are identical with those specified,
be used LASER PRODUCT
Safety components are marked by the symbol ! .

Lead free
 1-

INSTRUCTIONS ON CD PLAYABILITY

Customer complaint
"CD related problem"

Set remains closed!

1
check playability

playability N
ok ?

Y 3
For flap loaders (= access to CD drive possible)
"fast" lens cleaning cleaning method 4 is recommended

check playability

playability N
ok ?

Play a CD
for at least 10 minutes

check playability

playability N
ok ?

add Info for customer Exchange CDM

"SET OK" 2

return set

1 - 4 For description - see following pages

 1-

INSTRUCTIONS ON CD PLAYABILITY

1 4
PLAYABILITY CHECK LIQUID LENS CLEANING
Before touching the lens it is advised to clean the
surface of the lens by blowing clean air over it.
For sets which are compatible with CD-RW discs
This to avoid that little particles make scratches on
use CD-RW Printed Audio Disc ....................7104 099 96611
the lens.
TR 3 (Fingerprint)
TR 8 (600μ Black dot) maximum at 01:00
Because the material of the lens is synthetic and coated
• playback of these two tracks without audible disturbance with a special anti-reflectivity layer, cleaning must be done
playing time for: Fingerprint t10seconds with a non-aggressive cleaning fluid. It is advised to use
Black dot from 00:50 to 01:10 “Cleaning Solvent
• jump forward/backward (search) within a reasonable time

The actuator is a very precise mechanical component and

may not be damaged in order to guarantee its full function.
For all other sets Clean the lens gently (don’t press too hard) with a soft and
use CD-DA SBC 444A..................................4822 397 30245 clean cotton bud moistened with the special lens cleaner.
TR 14 (600μ Black dot) maximum at 01:15
TR 19 (Fingerprint) The direction of cleaning must be in the way as indicated in
TR 10 (1000μ wedge) the picture below.

• playback of all these tracks without audible disturbance

playing time for: 1000μ wedge t10seconds
Fingerprint t10seconds
Black dot from 01:05 to 01:25
• jump forward/backward (search) within a reasonable time

2
CUSTOMER INFORMATION

It is proposed to add an addendum sheet to the set which

informs the customer that the set has been checked
carefully - but no fault was found.
The problem was obviously caused by a scratched, dirty or
copy-protected CD. In case problems remain, the customer
is requested to contact the workshop directly.
The lens cleaning (method 3) should be mentioned in the
addendum sheet.

The final wording in national language as well as the printing

is under responsibility of the Regional Service Organizations.
 2-1

Software Version Check & Upgrade

Upgrade software

1.Download the software from Philips support website

http://www.philips.com/support

2.Load the Software CD Disc or USB device with software, software upgrade procedure starts
automatically and it will be finish until you hear a long ‘ding’ voice.

Software check

1, Make sure that the unit is disconnected with the AC supplier.

2, Keep the “PLAY/PAUSE”and“STOP” buttons depressed at the same time while plugging the
AC cord. the LCD Display shows:

MMMdd yy

3, Press the “PLAY/PAUSE” button once again , the LCD Display will shows:

M302 Vxx
 2-2

Malfunction follow check chart

 3-1 3-1

Disassembly Diagram

A.Loosen these Screws(both sides & back) B.Use thin screwdriver to unclench Top Cover C.Loosen these screws to remove Decoder Board

Side View

Back View
C

D.Loosen these screws to remove Dustproof Cover E.Loosen these screws to remove CD Loader Dirver F.Loosen these screws to remove Power Board

Both sides

D
F
E

H.Loosen these screws to remove Display Board

H
 4-1 4-1

Block Diagram

CD DECODER BOARD 9V_2314 manostat

+27V

9V +27V +27V
MECHANISM circuit
Switch control
RF
FLASH
CD DRIVER M5V
AC110-220
SANYO DA11VF M3.3V
MCU_5V
+5.7V
MOTOR Driver Manostat +5.7V
(AM5766 FM) circuit M5V
+5.7V

M5V
M5V Switch control
TP75S
CD MECHANISM
ASA WXD-8210D
OPEN/CLOSE SWITCHING POWER
Driver

M5V

Main chipset STANDBY

EEPROM I2C BUS
24C16
M5673 +27V
DISC/USB L&R

FM ANT M5V
INPUT SELECT SPEAKERS
Audio processor 9V 2314 AMP SP-4P
4 OHM
FM block L OUT 1
&EQ & VOL CTRL
(SI47XX) TPA3123D2 2
3
FM L/R R OUT
4
25W+25W
AUX1 L/R SPEAKERS
MUTE1 4 OHM
PT2314
AUXR AUXL
MP3-LINE L/R
AUDIO L&R M5V

Earphone AMP
MUTE0
(PT2309)
STANDBY
HP LOUT HP ROUT

MCU_5V
AUX2 IN

HP ROUT
LCD driver & MCU &RTC

HP LOUT
TMS87P08

HEADPHONE
M5V MCU_5V SW?
POWER KEY

KEY
REMOTE

USB IR LCD A
matrix
A
DISPLAY KEY CONTROL BLOCK
 4-2 4-2

Wiring Diagram

DISPLAY BOARD

CD AC IN
MECHANISM

POWER BOARD
DECODER BOARD
 5-1 5-1

Display Board -- Circuit Diagram

J1000A 5V
LCD U1000
MP3 IN

R1001 R1003
LCD R1020
10K 4.7K R1004 56

10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
26
27
28
10

1
2
3
4
5
6
7
8
9
LED R1002 Q1000 LED1000
8050 LED

com1
com2
com3
com4
com5
com6
com7
R1000 47K 4.7K
C1000
100P
R1005 47K Q1003

seg10
seg11
seg12
seg13
seg14
seg15
seg16
seg17
seg18
seg19
seg20
seg21
100P 5V 8550

seg1
seg2
seg3
seg4
seg5
seg6
seg7
seg8
seg9
C1001 R1007 R1009
MP3_R
MP3_L

2K 100
AGND

CN1001 3PIN/2.0 REMOTE

43seg1
42seg2
41seg3

39seg5
38seg6
S1000

40seg4
3
2
1

50 com7
49 com6
48 com5
47 com4
46 com3
45 com2
44 com1
REM
GND U1001
R1006 Vcc

SEG1
SEG2
SEG3
SEG4
SEG5
SEG6
COM7
COM6
COM5
COM4
COM3
COM2
COM1
4.7K C1005104
1 37 seg7
cup2 SEG7 LED1001
1
2
3

CN1000 J1001 2 36 seg8 5V

C1003104 cup1 SEG8 R1008
GND 6 IR C1002 3 35 seg9
4 GND VDD3 SEG9
D+ 5 47U/6.3V C1004 3V 4 34 seg10 1.2k
3 Shield 104 VDD SEG10
D- 4 5 33 seg11
2 GND VDD1 SEG11 LED
VBUS 3 6 32 seg12 Q1001
1 D+ GND SEG12
2 C1008 7 31 seg13 R1013
4PIN/2.0 D- XOUT SEG13 ECO_POWER
1 8 30 seg14
vbus XIN SEG14
K0 9 29 seg15 1.2K
USB 15P X1000 R1012 STB SEG15 PNP
10 28 seg16
3V OSCIN SEG16
30K ECO_POWER
11 27 seg17

STANDBY
C1009 CLK SEG17
J1002A IR 12 26 seg18
IR SEG18

SEG21
SEG20
SEG19
MUTE
DATA
15P 32.768

KS2
KS1
KS0
K3
K2
K1
K0
3V
headphone

DBB U1001 C1012

2
SW1000

seg2123
seg2024
seg1925
R1014

17
handshake
5V C1013
13
14
15
MUTE 16

18
19
20
21
22
750
R1010 47K 3 1 100U/16V 104
IN GND

OUT
R1015

SDA
SCL
C1006 C1010 C1011 1.2k
K3

K2

K1

100P
104
K0

R1011 47K 220U/16V IC1000

100P |<< open/close standby + 1117-ADJ
C1007
SW1001 SW1002 SW1003 SW1004 IR CN1002
1
J1002B MUTE
KS2

2
J1002C ECO_POWER
_ volume- stop mode 3
5V
SW1005 SW1007 SW1009 SW1011 4
C1014 GND
5
handshake
KS1

104 6
SCL
volume+ source play 7
PH-MUTE

>>| SDA
H_OUTR
H_OUTL

SW1006 SW1008 SW1010 SW1012 8

LED
PGND

9
9P
KS0

CN1003 4PIN/2.0
4
3
2
1
 5-2 5-2

Display Board -- Layout Diagram

 6-1 6-1

Decoder board -- Circuit Diagram -- Part1

J1
CON2.54-2
1 5.7V_IN STANDBY
STANDBY 3
2 GND

J9
CON2.54-2
1 VCC_27V
GND MK1
2
MK2
MK3
MK4

5.7V_IN VCC_5.7V
R1 Q1
47K CES2307
H1
CE1 + + CE2 9 2
9 2
R2 8 3
8 3
CD11X/220UF16V/D6.3H7 33K CD11X/220UF16V/D6.3H7 7 4
7 4
6 6 5 5

1
1
R3
1K

C1
3

2.2uF/16V R4 4.7K
Q2 2 STANDBY
2N3904
R5
1

22K

VCC_27V CE3 R6 R7 Q3 A27V

CD11/100UF35V/D8H11 5.6 1/2W 47K 8550,DIP
1 3

+
2

R8
1K
R9 R10 C2
3

10K 22K 2.2uF/16V

STANDBY 2 Q4
2N3904
1
 6-2 6-2

Decoder Board -- Circuit Diagram -- Part2

VCC_5.7V 5V CD_L
CD_L 3
D12 CD_R
VREF_16 CD_R 3
J2 IN4001/DIP 5V CD_TMS
CD_TMS 3
SF-P200Z(FPC) 1 2 MUTE_CD
MUTE_CD 3
CB1 CE4 SDA_CD
SDA_CD 3
0.1uF CD11X/10UF16V/D4H7 SCL_CD
SCL_CD 3
Q6 J8 CD_IR
CD_IR 3

1
1 HAVC R139 3.3/0805 R11 220 8550,DIP R12 220 CON2.0-5 R13 R14 FM_RST
VC LOAD- FM_RST 3
2 2 Q5 2 1 L21 FB/220 10K 10K R16 LCD_CS
VCC 3V3SD LCD_CS 3
3 R15 33K TNI 8550,DIP 2 L22 FB/220 LOAD+ 51K TRACK C3 0.01uF VREF_16 LCD_CLK
E MDPUH OPEN_SW LCD_CLK 3
4 CB2 CE5 3 LCD_DATA
D MAPUH LOAD- GND VCC_5.7V R17 XTRACK LCD_DATA 3
5 4 R19 6.8K

3
A MBPUH 0.1uF CD11X/220UF16V/D6.3H7 CLOSE_SW 300mA 3.9K LED_C
B 6 5 LED_C 3
7 MCPUH LOAD+ SPINDLE R20 1K XSPINDLE STAN
C STAN 3
8 R21 33K TPI R18 680 ROT_A

82K/39K
F TRCLOSE VREF_16 ROT_A 3
CE6 CB3 CB4 ROT_B

560K/0
9

R23
GND LD ROT_B 3
10 Q8 C4
LD VCC_5.7V

3
11 R22 680 8050,DIP CD11X/470UF10V/D8H7 0.1uF 0.1uF 0.47uF
VR MDI TROPEN Q7 SPIN-
MD 12 2 2
13 FOCUS+ 8050,DIP SPIN+

R24
F+ TRACK- TRACK-
T- 14
15 TRACK+ R25 C5 C6 R26 MUTE34 TRACK+

1
T+ FOCUS- 1K 390pF 390pF 1K
F- 16

28
27
26
25
24
23
22

30
21
20
19
18
17
16
15
MUTE
BIAS
VINTK

OPOUT

VOTK+
OPIN
VINLD
GND

GND

VOLD+
TRB_2

VCTL

VCC2

VOTK-
VOLD-
SEV_3V3 3V3SD_IC V18_CORE 3V3SD U1
AM5766FM

REGO2

REGO1
VINSL+

VOTR+

VOFC+
VOSL+
TRB_1

VOTR-

VOFC-
VOSL-
VINFC

VCC1
FWD

GND
REV
CB6 CB7
CB5 0.1uF 0.1uF MUTE34
0.1uF CD_TMS R135
VCC_5.7V

29

10
11
12
13
14
LIMIT 1K

1
2
3
4
5
6
7

8
9
MUTE_CD + CE9 R136
VREF_16 CD11X/10UF16V/D4H7 1K
XSLEGP RESETJ FOCUS+
M33V_PAD
XSPINDLE R27 R28 R137 R29 FOCUS-

3
10K 4.7K 10K 10/0.5W SL-
2 Q11 VCC_5.7V SL+
XFOCUS 2N3904
XTRACK Q9

1
L2 MDI

1
M33V 8550,DIP
FB/220 CD_IR D1 R138 C64 2
40mA 1N4148 10K 0.01uF

128
127
126
125
124
123
122
121
120
119
118
117
116
115
114
113
112
111
110
109
108
107
106
105
104
103
R32
20K SLEGP C7 0.047uF VREF_16

3
1
M33V

VDD_CORE

XGPIOI2/IRC
GND_CORE
VDD_PAD
XAVDD_D33
MDI
TRO
FOO

FMO
VREF16
BTN_ADIN3
BTN_ADIN2
BTN_ADIN1

GND_PAD
XGPIOJ2
XGPIOJ1
XGPIOJ0
XGPIOI7
XGPIOI6
XGPIOI5
XGPIOI4
XGPIOI3
GPWM
XAVSS33_1
DMO
XAVD33_1
R33 CE7 3V3SD R30 R31 R35 0 XSLEGP
CE8 + R36 CB8 CB9 R37 15K 3.3K
15 CD11X/47UF16V/D5H7
CD11X/470UF10V/D8H710K 0.1uF 0.1uF 12K
1

FOCUS R40 6.8K XFOCUS

2 LDO 1 102 LED_C R38
TPI LDO XGPIOI1/PWM0_0(O) 4.7K/NC R39 C8 0.01uF VREF_16
2 TP1 XGPIOI0/LCDWRJ(O) 101
LD Q10 TNI 3 100 43K
TP2 XGPIOH7/LCDRDJ(O)
2

8550,DIP MCPUH 4 99 RESETJ

3

SEV_3V3 MBPUH MC XPRSTB FM_RST

5 MB XGPIOH6/LCDCSJ(O) 98
D2 MDPUH 6 97
1N4148 C9 MAPUH MD XGPIOH5/LCDA0(O)
7 MA XGPIOH4/DATA7(B) 96
0.1uF 8 95 STAN
HAVC XAVDD33_2 XGPIOH3/DATA6(B) ROT_A
9 94
1

CE11 HAVC XGPIOH2/DATA5(B) ROT_B J3

10 V12 XGPIOH1/DATA4(B) 93
CE10 CB10 CD11X/10UF16V/D4H7 11 92 CON2.0-6
CD11X/10UF16V/D4H7 0.1uF CB11 0.1uF XAVSS33_2 XGPIOH0/DATA3(B) LCD_DATA
12 TELP XGPIOG7/DATA2(B) 91
FELPFO 13 90 LCD_CLK SPIN+ 1
CB12 TP1 TELPFO MPXOUT1 XGPIOG6/DATA1(B) LCD_CS SPIN- SPIN+
14 MPXOUT2 XGPIOG5/DATA0(B) 89 2 SPIN-
0.1uF TP2 SBLPFO 15 88 SL+ 3

U2
TP3 MPXOUT3 XGPIOG4/USI_CLK R44 10K 3V3SD SL- SLED+
16 COSP XGPIOG3/USI_DI 87 4 SLED-
CB13SEV_3V3 C10 1uF/16V 17 86 LIMIT 5
CB14 0.1uF COSN XGPIOG2/USI_DO LIMIT1
18 XAVDD33_3 VDD_PAD 85 M33V_PAD 6 LIMIT2
0.1uF 19 84
VTB GND_PAD CB15
20 VTP XGPIOF3/SD_MS_DET 83
CE12 21 82
M33V_LDO XAVSS33_3 XGPIOF2/SD_MS_PWR 0.1uF
22 XAVSS33_LDO XGPIOF1/SD/MS_CLK(O) 81

ALi M5673
CB17 CD11X/10UF16V/D4H7 CB16 23 80
0.1uF 0.1uF V18 XAVDD33_LDO XGPIOF0/SDCMD(B)/MSBS(O)
24 XAVDD18_LDO XGPIOE7/SDD3(B) 79
25 78 V18 L3
M33V_CKG XAVDD33_CKG XGPIOE6/SDD2(B) FB/220
26 XTALI XGPIOE5/SDD1(B) 77
R45 27 76
XTALO XGPIOE4/SDD0(B) RF_1V8
C11 0 CE13 28 75
30pF CD11X/100UF16V/D6.3H7 XAVSS33_CKG XGPIOE3/SD_MS_WP
RF_1V8 29 XAVDD18_1 XGPIOE2/DOCD_CLK(O) 74
CB18 30 73
C13 Y1 0.1uF XAVSS18_1 XGPIOE1/DOCD_DATI(I) L4
31 XPAD_BICAFL XGPIOE0/DOCD_DATO(O) 72
30pF R46 16.9344MHz C12 32 71 FB/220
100K CD_L 0.082uF/NC XPAD_BOCAPL XGPIOD7/SPDIF
33 XPAD_LINEOUTL XGPIOD6/I2S_WCLK 70 V18_CORE
C14 34 69 CLOSE_SW
0.082uF/NC XPAD_BICAPR XGPIOD5/I2S_DI OPEN_SW CB19
35 XPAD_BOCAPR XGPIOD4/I2S_DO 68
CD_R 36 67 TRCLOSE U4 0.1uF
XPAD_LINEOUTR XGPIOD3/I2S_REFCLK TROPEN 24C02 M33V L5
37 XAVSS33_AUD XGPIOD2/I2S_SCLK 66
38 65 SDA_CD R49 330 SDA1 5 4 FB/220
AUD_3V3 XAVDD33_AUD XGPIOD1/I2CM_DAT(B) SDA VSS
SCL_CD R50 330 SCL1 6 3
SCL A2 SEV_3V3
7 TEST A1 2
MCU5V 8 1 CB20
XGPIOD0/I2CM_CLK(O)

CE14 CB21 VDD A0 0.1uF

CD11X/10UF16V/D4H7 0.1uF L6
CB23 FB/220
XGPIOC0/SFCSB
XGPIOC1/SFSCK

XGPIOC3/URRX
XGPIOC2/URTX
XGPIOB6/SFDO
XPAD_MICBIAS
XPAD_LINEINR

0.1uF
XPAD_LINEINL

XGPIOB7/SFDI
XPAD_XVREF
XPAD_MICIN

AUD_3V3
XPAD_SFGN
XPAD_SFGP
XPAD_V08R
XPAD_V15R

GND_CORE
XPAD_V08L
XPAD_V15L

VDD_CORE

GND_PAD
VDD_PAD
FMINR

FMINL

L7
XDM
XDP

FB/220
3V3SD
3V3SD_IC
39
40
41
42
43
44
45
46
47
48
49
50
51
52
53
54
55
56
57
58
59
60
61
62
63
64

R51 4.7K/NC CD_TMS 3V3SD

R52 10K LIMIT R53 10K M33V L8

R54 10K FB/220
R55 4.7K CD_IR V18_CORE M33V_PAD F_CLK
F_CS M33V_PAD
R56 4.7K/NC MUTE_CD F_DI CB24
F_DO 0.1uF
R57 68K SDA_CD
L9 L10
R58 68K SCL_CD CE18 FB/220 FB/220
CD11X/10UF16V/D4H7 J4
M33V_CKG
CE15 CON2.0-4
CD11X/10UF16V/D4H7 CB25
R59 0 D3 D+ 4 3V3SD 0.1uF
CE17 R60 0 IN4001/DIP D- 3 J4 ⱘ2ˈ3㛮䍄㒓ᣝᏂߚ㒓㾘߭ 20mA
CE16 CD11X/10UF16V/D4H7 20mA 2 L11
1 2 1
CD11X/10UF16V/D4H7 VCC_5.7V ᬍ㑶㡆 FB/220
CB26 R61
M33V_LDO
R63 0/NC CE20 CE19 0.1uF 22K R62 CB27 R64
CD11X/10UF16V/D4H7 CD11X/100UF16V/D6.3H7 100K 0.1uF 100K CB28
AUD_3V3
0.1uF
CB29 R65 L12
0.1uF 10K SPIN- F_CS 1 8 FB/220
F_DI CS# VCC HOLD#
2 DO HOLD# 7 3V3SD
R66 R67 WP 3 6 F_CLK
1.5K 22K GND 4 WP# CLK F_DO CB30
GND DI 5
0.1uF
R68
10K SPIN+ U5
EN25F20
R69 R70
1.5K 27K
 6-3 6-3

Decoder Board -- Circuit Diagram -- Part3

VCC_5.7V FM5.7V
L13
FB/600

C16 R71 C17

10uF/10V 20K 470pF/NC SCL_CD
AUX1_R_IN SCL_CD 2
AUX1_R SDA_CD
SDA_CD 2
CD_TMS
CD_TMS 2
CD_R
CD_R 2
CD_L
CD_L 2
MUTE_CD
MUTE_CD 2
STANDBY
STANDBY 1
CD_IR
CD_IR 3
C20 C21 FM_RST
FM_RST 2
1000pF 1000pF LCD_CS
LCD_CS 2
LCD_CLK
LCD_CLK 2
LCD_DATA
LCD_DATA 2
LED_C
LED_C 2
STAN
STAN 2
P2 U6 ROT_A
21

20

19

18

17

16
TP11 IF-05P ROT_A 2
SI4704 ROT_B
ROT_B 2
7
GPO1

GPO2/IRQ
GND

NC.

DFS
GPO3/DCLK
6
TP5 C22 R81
5
4 C23 R82 C26 10uF/10V 20K
3 C24 1 15 10uF/10V 20K 470pF/NC MP3_LINK_R
100pF NC DOUT C25 0.47uF AUX1_L_IN AUX1_L
2
1 FM_ANT 2 14 FM_LIN
FMI LOUT C27 0.47uF C28 CB31 C30 CB32
3 13 FM_RIN 1000pF 0.1uF 1000pF 0.1uF
R83 0/NC RFGND ROUT FM5.7V

10uF/10V
SHOUT_ANT 4 12 R85 C29 R86
TP4 R84 33 TXO GND 10/0805 10uF/10V 20K

2700pF

2700pF
FM_RST 5 11 MP3_LINK_L
RST VD/VDD 80mA
R87 C35
0.27uH

0.12uH

C34 30K 470pF/NC

CB33 + CE21 10uF/10V CDR CE22 CB34 9.1V R88 A27V

C31
0.1uF CD11X/100UF16V/D6.3H7 FM_RIN FM_R CD11X/220UF16V/D6.3H7 0.1uF 560R 1/2W
RCLK
SCLK

SDIO
SEN

CDL
VIO

C32

C33
+

14

13

12

11

10
10

1
D4
L14

L15

R89

TREBL_L
L_IN3

L_IN4

LOUD_L

R_IN1

R_IN2

R_IN3

R_IN4

LOUD_R

R_IN

TREBL_R

AGND

VDD
R_OUT
1K 9.1V 0.5W
U7
PT2314
R93 C38
C36 R91 D5 C37 30K 470pF/NC
SCL_CD R92 220 R90 1uF/16V 10K 3.3V/SMD 10uF/10V

BOUT_R
10K FM_LIN FM_L

BOUT_L

OUT_R

OUT_L
L_OUT

BIN_R

DGND
SDA_CD R94 220

BIN_L

DATA
L_IN2

L_IN1

L_IN

REF
CLK
15

16

17

18

19

20

21

22

23

24

25

26

27

28
Y3 R95
32.768KHz 0 CE23 CD11X/22UF16V/D4H7

+
0.15uF

0.15uF

0.15uF

0.15uF
C41 R97 C46 R96 300 SCL_CD
C39 C40 10uF/10V 47K 470pF/NC
22pF 22pF CD_R CDR R98 300 SDA_CD

10uF/10V

C42

C43

C44

C45
C47 10uF/10V
L_OUT

ሑৃ㛑䴴䖥IC 㛮 R99 R100 C49 10uF/10V

10K 10K R_OUT

C48
C50 R101 C51
10uF/10V 47K 470pF/NC
CD_L CDL

D6 1N4148 D7 1N4148 VCC_5.7V

MUTE_CD 1 2 MUTE1 1 2 R102 10 MUTE R103 5.6K
PH_MUTE

1
D9 1N4148 D8
MUTE_MCU 1 2 IN4001/DIP

D10 1N4148 R104 22K CB35 0.1uF

2
PH_MUTE 1 2
U8
PT2309

H_OUTR CE24 CD11X/220UF16V/D6.3H71 8 CE25 CD11X/220UF16V/D6.3H7

+
OUT1 VDD

+
R105 100K 2 7 CE26 CD11X/220UF16V/D6.3H7 H_OUTL

+
R106 4.7K/0805 MUTE OUT2
R_OUT C52 10uF/10V 3 6 CE27 CD11X/47UF16V/D5H7

+
IN1 BIAS
4 5 C53 10uF/10V R107 4.7K/0805 L_OUT
GND IN2

3
R108 4.7K
MUTE1 2 Q14 + CE28
2N3904
CD11W/1UF50V/D4H5

1
R109

10K

J5
CON2.0-4
4 GND
3 H_OUTR
H_OUTL 5.7V_IN D11 MCU5V
2
1 PH_MUTE IN4001/DIP CE29
1 2 CD11X/100UF16V/D6.3H7

VCC_27V
J6 +
CON2.0-9 D13 L16 FB/DIP
10 STAN IN60/DIP
9 R129 0 LED_C
8 2 1 CD_IR R130 100/NC SDA_CD + CE30
7 MUTE_MCU MCM302 CD1503 + CE31
6 STANDBY CD263/470UF35V/D10H16
5 R131 0 MCU5V CD263/470UF35V/D10H16 U9

30
29
28
27
26
25
4 GND R132 100/NC SCL_CD R129 0 NC TPA3123D2
3 LCD_CS R124 4.7K

30
29
28
27
26
25
2 LCD_CLK R125 4.7K 1 24
LCD_DATA R126 4.7K R130 NC 100 R110 2.2K PACCL PGNDL ሑৃ㛑䴴䖥䕧ߎ㛮
1 MCU5V STANDBY 2 23 CE32
P3 SD PGNDL L17 L18 33uH/3.5A CD11/680UF35V/D10H20
AV2-8.4-13D R131 0 NC 3 22 OUTR+
AUX1_R_IN TP6 R111 4.7K PVCCL LOUT
3

+
2 AUX1_L_IN TP7 MUTE 4 21 C54 0.22uF/0805 FB/100/0805/5A
J7 R132 NC 100 MUTE BSL R127 R112 C55
1
CON2.0-3 4 R_OUT R113 10K CE33 1uF/50V 5 20 R114 100K P4
GND LIN AVCC 5.6 560/1/4W 0.47uF/dilun WP-416
1 5

+
2 MP3_LINK_R R133 NC 10K L_OUT R115 10K CE34 1uF/50V 6 19 R116 100K TP8 OUTR+ 1
MP3_LINK_L RIN AVCC C62 TP9 OUTL+
3 2

+
7 18 GND 3
R134 NC 10K BYPASS GAIN0 1800pF GND 4
R118 C56 C57 R119 R120 + CE35 8 GND GAIN1 17 5
J10 33K 22pF 22pF 33K 100K CD11/1UF50V/D5H11 6
CON2.0-3/NC J10 NC CON2.0-3 C59 9 16 C58 0.22uF/0805 CE36
GND GND BSR L19 L20 33uH/3.5A CD11/680UF35V/D10H20
1
2 ROT_A R133 10K/NC 1uF/16V 10 15 OUTL+
ROT_B R134 10K/NC PVCCR ROUT
3 MCU5V

+
11 14 FB/100/0805/5A
VCLAMP PGNDR CB36 R128 R122 C60
12 PVCCR PGNDR 13
0.1uF 5.6 560/1/4W 0.47uF/dilun
C61 CB37 ሑৃ㛑䴴䖥䕧ߎ㛮
C63
1uF 0.1uF
1800pF
 6-4 6-4

Decoder Board -- Layout Diagram

 7-1 7-1

Power Board -- Circuit Diagram

 7-2 7-2

Power Board -- Layout Diagram

 8-1 8-1

Exploded View
 13-1
ACCESSORIES PARTS LIST
996520035692 MCM302/12 ACCESSORY PARTS
996500041018 FM ANTENNA WIRE 1.5m
994000004988 AC LINE CORD 1.8M(/12)
996510028347 AC LINE CORD 1.8M/ROUND PLUG VDE(/05)
996510019410 POWER CORD 1.8m UC/INMETRO(/55)

996500038637 POWER PLUG ADAPTOR(/55)

996510021101 PRC500-54 REMOTE CONTROL(/12)
996510022839 PRC500-54 REMOTE CONTROL(/55)
996510021098 MCM302/12 MAIN SPEAKER BOX(/12)
996510022841 MCM302/55 MAIN SPEAKER BOX(/55)

MECHNICAL&MISCELLANEOUS PARTS
CASING1 996510024636 FLAT FLEXIBLE CABLE 16PX230
D001 996510024658 MCD302 FUNCTION AL. SHEET
D002 996510021113 MCD302 DVD DOOR SPRING
D003 996510021111 MCD302 DVD DOOR(M302)
D004 996510021137 MCD302 DISPLAY LENS(LCD)

D005 996510021105 MCD302 FRONT CABINET

D009 996510021094 MCM302/12 CD CENTER BUTTON
D013 996510024718 MCD302 TOP COVER/ABS718
D014 996510021102 MCD302 DUSTPROOF COVER
D016 996510021108 MCD302 DVD DOOR BACKET

D023 996510021099 MCD302 BOTTOM CABINET

D024 996520033990 RUBBER PAD
D015 996510021096 DA11VF/WXD-8210D CD MECHANISM
D021 996510021106 POWER BOARD TP75ES-12(TP75ES)
D022 996510021095 DECODER EJS302CDBA-12(EJS302CD(/12)
996510022849 CD/MP3 DECODER EJS302CDB-55(/55)

ELECTRICAL PARTS - DISPLAY BOARD

D006 996510021134 MCD302 LCD BRACKET/ABS
D006A 996510021116 MCD302 LIGHT-GUIDE(PMMA)
IC1000 996510014857 IC AMC1117-0333J(SMD)
J1001 996510021114 HEADPHONE JACK/D.3.5/CKX-28A
J1003 996510021103 USB JACK A-TYPE 4P/VERTICAL

LED1000 996510021107 LED D3X4 1L034XW31B0CT201

LED1001 994000004947 LED DIODE D3 3B4SCB01 (BLUE)
S1000 996510021115 IR SENSOR 1MA81P14D1TD0001/36k
SW1000 994000004963 LIGHT TOUCH SW. TC103 H5
U1000 996510021135 LCD DISPLAY LCD-MCM302

U1001 996510021138 LCD DRIVER MODUL ZX935P-302

X1001 996510021097 CRYSTAL OSCILLATOR 32.768KHZ

Note: Only
l these
h parts mentioned
d in the
h llist are normall
service parts.
 10-1

Factory Parts List

D008 MCM302/12 DISPLAY BOARD(LCD)

R1008 CARBON FILM RESISTOR 1.2K 1/8W J-52
R1020 CARBON FILM RESISTOR 10 1/8W J-52
R1004 CARBON FILM RESISTOR 10 1/8W J-52
R1001 CARBON FILM RESISTOR 10K 1/8W J-52
R1006 CARBON FILM RESISTOR 1.2K 1/8W J-52
R1007 CARBON FILM RESISTOR 2K 1/8W J-52
R1009 CARBON FILM RESISTOR 100 1/8W J-52
R1012 CARBON FILM RESISTOR 30K 1/8W J
R1015 CARBON FILM RESISTOR 1.2K 1/8W J-52
R1013 CARBON FILM RESISTOR 4.7K 1/8W J-52
R1002 CARBON FILM RESISTOR 4.7K 1/8W J-52
R1003 CARBON FILM RESISTOR 4.7K 1/8W J-52
R1016 CARBON FILM RESISTOR 47K 1/8W J-52
R1017 CARBON FILM RESISTOR 47K 1/8W J-52
R1018 CARBON FILM RESISTOR 47K 1/8W J-52
R1019 CARBON FILM RESISTOR 47K 1/8W J-52
R1014 CARBON FILM RESISTOR 680 1/8W J-52
C1016 CHIP CERAMIC CAP.100p 50V K-5 H<7
C1017 CHIP CERAMIC CAP.100p 50V K-5 H<7
C1018 CHIP CERAMIC CAP.100p 50V K-5 H<7
C1019 CHIP CERAMIC CAP.100p 50V K-5 H<7
C1003 CHIP CERAMIC CAP.104p 50V K-5
C1004 CHIP CERAMIC CAP.104p 50V K-5
C1005 CHIP CERAMIC CAP.104p 50V K-5
C1 CHIP CERAMIC CAP.104p 50V K-5
C1010 CHIP CERAMIC CAP.104p 50V K-5
C1013 CHIP CERAMIC CAP.104p 50V K-5
C1008 CHIP CERAMIC CAP.15p 50V ±1p-5
C1009 CHIP CERAMIC CAP.15p 50V ±1p-5
C1002 ELECTROLYTIC CAP. 47u 6.3V M-5 4X6
C1012 ELECTROLYTIC CAP.100u 10V L-5 5X7
C1011 ELECTROLYTIC CAP.220u 10V M 6.3X7
D1000 DIODE 4148-52
LED1001 LED Φ3 3B4SCB01 (HIGH-BLUE)
LED1000 LED Φ3X4 1L034XW31B0CT201(CRYSTAL)
Q1000 TRANSISTOR 8050D-5
Q1001 TRANSISTOR 8550C-5
Q1003 TRANSISTOR 8550C-5
IC1000 IC AMC1117-0333J(SMD)
U1001 LCD DRIVER MODUL ZX935P-302
S1000 IR SENSOR 1MA81P14D1TD0001 (36kHz)
X1001 CRYSTAL OSCILLATOR 32.768KHZ φ2X6
SW1000 TACT SWITCH TC103 6X6X5 170G
SW1001 TACT SWITCH TC103 6X6X5 170G
SW1002 TACT SWITCH TC103 6X6X5 170G
SW1003 TACT SWITCH TC103 6X6X5 170G
SW1004 TACT SWITCH TC103 6X6X5 170G
SW1005 TACT SWITCH TC103 6X6X5 170G
SW1006 TACT SWITCH TC103 6X6X5 170G
SW1007 TACT SWITCH TC103 6X6X5 170G
SW1008 TACT SWITCH TC103 6X6X5 170G
SW1009 TACT SWITCH TC103 6X6X5 170G
SW1010 TACT SWITCH TC103 6X6X5 170G
SW1011 TACT SWITCH TC103 6X6X5 170G
SW1012 TACT SWITCH TC103 6X6X5 170G
J1003 USB JACK A-TYPE 4P/VERTICAL