Pub.

# BKIDK0522-EN

F2803-ELA
FOR M4900

Oct. 2016
 TABLE OF CONTENTS
GROUP CODE GROUP NAME PAGE
FREQUENTLY USED ITEMS
000001 FREQUENTLY USED ITEMS 1
ENGINE
A01000 HAND ACCELERATOR LEVER 2
A07000 STOP SOLENOID/ENGINE STOP WIRE 3
000100 CRANKCASE 4
000200 OIL PAN 5
000300 CYLINDER HEAD 6
000400 GEAR CASE 7
000501 HEAD COVER [OLD TYPE] ## S.No.<=3U0371 8
000502 HEAD COVER [NEW TYPE] ## S.No.>=3W0001 9
010000 MAIN BEARING CASE 10
010100 CAMSHAFT AND IDLE GEAR SHAFT 11
010200 PISTON AND CRANKSHAFT ## NOTE:ORDER BY REF.No.010 and 040 NEW PARTS. 12
010300 FLYWHEEL 13
010500 FUEL CAMSHAFT 14
020000 ENGINE STOP LEVER 15
020200 INJECTION PUMP 16
020400 GOVERNOR 17
020500 SPEED CONTROL PLATE 18
020600 NOZZLE HOLDER AND GLOW PLUG 19
020700 NOZZLE HOLDER [COMPONENT PARTS] 20
050000 WATER FLANGE AND THERMOSTAT 21
050100 WATER PUMP 22
060000 VALVE AND ROCKER ARM 23
060100 INLET MANIFOLD 24
060200 EXHAUST MANIFOLD 25
060300 AIR CLEANER 26
060400 AIR CLEANER [COMPONENT PARTS] 27
060701 MUFFLER [EXCEPT [CS]] 28
060702 UNDER MUFFLER [CS] 29
090600 UPPER GASKET KIT 30
090700 LOWER GASKET KIT 31
FUEL SYSTEM
A11000 FUEL TANK 32
A17000 FUEL FILTER 33
A18000 FUEL FILTER [COMPONENT PARTS] 34
COOLING WATER SYSTEM
A41000 FAN 35
A42000 WATER PIPE 36
A43000 RADIATOR 37
A45000 RESERVE TANK 38
ELECTRICAL SYSTEM
A54000 ALTERNATOR 39
A55000 ALTERNATOR [COMPONENT PARTS] 40
A56000 STARTER 41
 TABLE OF CONTENTS
GROUP CODE GROUP NAME PAGE
A57000 STARTER [COMPONENT PARTS] 42
A58000 BATTERY 43
B01500 SWITCH/SENSOR 44
B10400 SWITCH(PANEL BOARD)/RELAY 45
B14000 PANEL BOARD 46
B15000 PANEL BOARD [COMPONENT PARTS] 47
B32000 HEAD LIGHT 48
B33501 HAZARD LIGHT/TAIL LIGHT [OLD TYPE] ## S.No.<=12438 49
B33502 HAZARD LIGHT/TAIL LIGHT [NEW TYPE] ## S.No.>=12439 50
B51000 ELECTRICAL WIRING 51
 F2803-ELA FOR M4900
1 FREQUENTLY USED ITEMS 1
000001 FREQUENTLY USED ITEMS

ITEM PART QTY PART NAME WGT. REMARK S/N

010 52200-41212 1 SWITCH,STARTER 0.6160
020 37500-55212 1 SWITCH,HAZARD 0.0440 <=13932
020 R1401-53262 1 SWITCH,HAZARD 0.0440 >=13933
020 3C001-75040 1 SWITCH,HAZARD 0.0330
030 18510-63720 1 ASSY KEY,STARTER 0.0550
040 36330-75010 1 SWITCH,COMBINATION 0.1980
050 19434-73010 1 ASSY THERMOSTAT 0.1540 <=1D1169
050 19434-73014 1 ASSY THERMOSTAT 0.1540 >=1E0476
060 36730-75550 3 FUSE 0.0066 10A
070 35820-75560 4 FUSE 0.0044 15A
080 35080-34530 1 FUSE 0.0110 50A
090 15531-39010 1 SWITCH,OIL 0.0704
090 1A024-39010 1 SWITCH,OIL 0.0770
100 17580-16060 1 CAP.RADIATOR 0.0880
110 3A211-17460 1 HOSE,WATER UPPER 0.5280
120 3A211-17450 1 HOSE,WATER LOWER 0.4950
130 R1401-42270 1 ELEMENT,OUTER 1.1000
140 R2401-42280 1 ELEMENT,INNER 0.6600
150 38450-33870 2 BULB 0.0550 45W
160 17321-32430 1 CARTRIDGE,OIL FILTER 0.9900
160 16414-32430 1 CARTRIDGE,OIL FILTER 0.9900
160 HH164-32430 1 ENGINE OIL FILTER 1.1000
170 15521--43160 1 ELEMENT,FILTER 0.0000
170 1A001-43160 1 ELEMENT,FILTER 0.1650
180 15196-97010 1 V BELT,A 0.2728
190 33960-82630 2 FILTER 1.4300
 F2803-ELA FOR M4900
1 FREQUENTLY USED ITEMS 1
000001 FREQUENTLY USED ITEMS
190 HH330-82630 2 CARTRIDGE,OIL FILTER 1.5400
200 3A011-12110 1 MUFFLER 0.0000
210 32530-91530 2 BULB,LIGHT 0.0440 27W
220 31391-34360 2 BULB 0.0396 23W
230 31301-34370 2 BULB 0.0440 23/8W
 F2803-ELA FOR M4900
2 ENGINE 2
A01000 HAND ACCELERATOR LEVER

ITEM PART QTY PART NAME WGT. REMARK S/N

010 3A111-10223 1 LEVER HAND ACCEL. 2.5960
020 3A111-10230 1 GRIP 0.0858
030 33251-10320 1 SPRING ACCEL.LEVER 0.0264
040 33251-10270 1 CAP SPRING 0.0220
050 02576-50120 1 NUT LOCK 0.0242
060 3A111-10260 1 PLATE 0.0088
070 3A111-10380 1 PLATE ACCEL.LEVER 0.0462
080 04013-60120 2 WASHER PLAIN 0.0220
090 3A111-10390 2 WASHER 0.0110
100 3A211-10010 1 ASSY ROD ACCEL. 0.6820
110 02112-50080 2 NUT 0.0066
120 04012-50080 1 WASHER PLAIN 0.0022
130 05511-50218 1 PIN SPLIT 0.0022
140 3A011-32870 1 PIN SNAP 0.0022
150 3A211-10470 1 LINK ACCEL. 0.4840
160 T0070-44720 1 SPRING 0.0330
170 3A211-10170 1 ASSY ROD ACCEL.PEDAL 0.4840
180 02112-50080 1 NUT 0.0066
190 52300-34120 1 PIN SNAP 0.0022
200 3A011-10250 1 BOLT 0.0550
210 02116-50100 1 NUT 0.0088
220 45404-95770 1 END ROD 0.1100
230 02156-50080 1 NUT 0.0088
240 04512-60080 1 WASHER SPRING 0.0044
250 37410-42760 1 COVER PEDAL 0.0550
 F2803-ELA FOR M4900
3 ENGINE 3
A07000 STOP SOLENOID/ENGINE STOP WIRE

ITEM PART QTY PART NAME WGT. REMARK S/N

010 15471-60010 1 SOLENOID,STOP 0.7700
020 01125-60816 2 BOLT 0.0220
030 17331-60150 1 LEVER,STOP 0.0550
040 15471-60162 1 LEVER STOP 0.0154
050 04012-50060 3 WASHER,PLAIN 0.0022
060 05525-60600 3 PIN,SNAP 0.0022
080 3F260-57270 1 CLAMP 0.0132
090 34070-44220 1 HOLDER,WIRE 0.0440
100 01023-50620 1 BOLT,SEMS 0.0132
110 02012-60060 2 NUT 0.0110
120 3A011-10360 1 COVER,ENGINE STOP 0.0044
130 34070-44240 1 PIN,JOINT 0.0110
140 T0070-44260 1 SCREW 0.0110
150 04011-50100 1 WASHER,PLAIN 0.0044
160 02771-50100 1 NUT,FLANGE 0.0110
170 3A011-10330 1 ASSY WIRE,E/G STOP 0.2200
 F2803-ELA FOR M4900
4 ENGINE 4
000100 CRANKCASE

ITEM PART QTY PART NAME WGT. REMARK S/N

010 16459-01010 1 COMP.CRANKCASE 165.00
020 17391-96160 3 PLUG EXPANSION 0.0066
030 15221-03380 8 CAP SEALING 0.0374
040 15221-03390 1 CAP SEALING 0.0660
050 15221-03390 1 CAP SEALING 0.0660
060 16271-96160 1 PLUG EXPANSION 0.0550
070 15521-96020 6 PLUG 0.0066
080 15521-96030 2 PLUG 0.0154
090 05012-00408 2 PIN STRAIGHT 0.0022
100 05012-00609 2 PIN STRAIGHT 0.0066
110 05012-00612 2 PIN STRAIGHT 0.0066
120 05012-01018 1 PIN STRAIGHT 0.0264
130 15221-33650 1 PIN PIPE 0.0088
140 15521-96020 1 PLUG 0.0066
150 15321-73340 1 PIPE WATER RETURN 0.0352
160 15221-33700 1 O RING 0.0022
170 15221-33610 1 PLUG 0.0198
180 15021-33660 1 GASKET 0.0022
190 17331-35012 1 ASSY PUMP OIL 1.1660
200 15296-35150 1 GASKET OIL PUMP 0.0022
200 1A021-35150 1 GASKET OIL PUMP 0.0022
210 01053-50648 4 BOLT 0.0220
220 04512-60060 4 WASHER SPRING 0.0022
230 15401-35660 1 GEAR OIL PUMP DRIVE 0.4400
240 05712-00410 1 KEY FEATHER 0.0022
250 15221-35682 1 NUT FLANGE 0.0308
 F2803-ELA FOR M4900
4 ENGINE 4
000100 CRANKCASE
260 15602-33110 1 FLANGE OIL FILLER 0.2200
270 15625-32890 1 GASKET 0.0022
280 01123-50822 2 BOLT 0.0264
290 15852-33140 1 PLUG OIL FILLER 0.0836
290 E9151-33140 1 PLUG OIL FILLER 0.0374
300 04811-50300 1 O RING 0.0022
300 04817-50300 1 O RING 0.0022
 F2803-ELA FOR M4900
5 ENGINE 5
000200 OIL PAN

ITEM PART QTY PART NAME WGT. REMARK S/N

010 17394-01610 1 OIL PAN 37.400
020 16478-01620 1 GASKET OIL PAN 0.0572
030 01133-51028 20 BOLT 0.0594
040 17377-91010 2 BOLT 0.1760
050 01133-51040 2 BOLT 0.0660
060 01173-51080 2 BOLT 0.1078
070 15601-91070 2 BOLT 0.1452
080 04512-60100 4 WASHER SPRING 0.0044
090 15221-33750 2 PLUG 0.0704
090 16326-33750 2 PLUG DRAIN 0.0550
090 13901-33750 2 PLUG DRAIN 0.0550
100 6C090-58960 2 GASKET 0.0110
110 17391-32110 1 FILTER OIL 0.5500
120 01153-50814 1 BOLT 0.0198 <=4Y0300
120 01123-60814 1 BOLT 0.0220 =>5A0001
140 04811-00180 1 O RING 0.0022
140 04817-00180 1 O RING 0.0022
150 16478-36410 1 GAUGE OIL 0.0660 <=4J0372
150 16478-36412 1 GAUGE OIL 0.0660 =>4L0001
160 15736-36420 1 GUIDE OIL GAUGE 0.0660
170 16484-33640 1 PLUG OIL GAUGE 0.0044
 F2803-ELA FOR M4900
6 ENGINE 6
000300 CYLINDER HEAD

ITEM PART QTY PART NAME WGT. REMARK S/N

010 15221-01750 1 HOOK ENGINE 0.0880
020 16415-01752 1 HOOK ENGINE 0.2530
030 01123-60816 1 BOLT 0.0220
040 15471-91530 1 STUD 0.0220 <=1Y8640
040 15221-91530 1 STUD 0.0242 =>2A0402
050 02156-50080 1 NUT 0.0088
060 04512-60080 1 WASHER SPRING 0.0044
070 16459-03040 1 COMP.CYLINDER HEAD 55.880 <=4N0340
070 16459-03044 1 COMP.CYLINDER HEAD 53.460 =>4Q0001
080 15221-03370 15 CAP SEALING 0.0220
090 15221-03490 1 CAP SEALING 0.0440
100 15261-96010 2 PLUG 0.0044
110 17321-13580 5 GUIDE INLET VALVE 0.0330
120 17321-13560 5 GUIDE EXHAUST VALVE 0.0440
120 1C010-13560 5 GUIDE VALVE EXHAUST 0.0550
130 16415-13620 5 SEAT INLET VALVE 0.0220
140 16415-13612 5 SEAT EXHAUST VALVE 0.0220
150 19013-03450 22 BOLT CYLINDER HEAD 0.1694
160 16484-03310 1 GASKET CYLINDER HEAD 0.3080
 F2803-ELA FOR M4900
7 ENGINE 7
000400 GEAR CASE

ITEM PART QTY PART NAME WGT. REMARK S/N

010 17127-04030 1 COMP.CASE GEAR 10.120 <=2K0917
010 17127-04033 1 COMP.CASE GEAR 8.8000 =>2L0445
020 16241-96020 2 PLUG 0.0330
030 04811-00360 1 O RING 0.0044
030 04817-00360 1 O RING 0.0022
040 05012-00612 2 PIN STRAIGHT 0.0066
050 17331-32610 1 SUPPORT OIL FILTER 0.6050
060 17326-32620 1 GASKET 0.0110
070 01123-50825 3 BOLT 0.0286
080 04811-00150 2 O RING 0.0022
080 04817-00150 2 O RING 0.0022
085 04811-00200 1 O RING 0.0022
085 04817-00200 1 O RING 0.0242
090 16221-56280 1 PIN START SPRING 0.0110
100 17331-32880 1 COVER 0.1650
110 17331-32910 1 COMP BOLT 0.1540
115 17331-32900 1 BOLT 0.1320
120 04811-00150 1 O RING 0.0022
120 04817-00150 1 O RING 0.0022
130 19202-96830 1 O RING 0.0220
140 17326-04132 1 GASKET GEAR CASE 0.0660
150 01123-50860 3 BOLT 0.0440
160 01153-50870 3 BOLT 0.0572
170 17367-91010 2 BOLT 0.0110
180 01153-50880 2 BOLT 0.0660
190 17367-91020 3 BOLT 0.0770
 F2803-ELA FOR M4900
7 ENGINE 7
000400 GEAR CASE
200 17367-91030 2 BOLT 0.0836
210 04512-60080 5 WASHER SPRING 0.0044
220 04012-50080 1 WASHER PLAIN 0.0022
230 15521-32290 1 JOINT PIPE 0.1100
230 15521-32293 1 JOINT PIPE 0.1100
230 1A021-32290 1 JOINT PIPE 0.1100
240 17391-36950 1 SPRING 0.0110
250 15521-36930 1 SEAT VALVE 0.0330
260 19202-04140 1 SEAL OIL 0.0330
270 07715-03213 1 BALL 0.0088
280 15521-73320 1 FLANGE WATER RETURN 0.0880
290 15766-73330 1 GASKET WATER FLANGE 0.0044
290 1A021-73330 1 GASKET RETURN FLANGE 0.0022
300 01023-50620 3 BOLT 0.0132
310 17321-32430 1 CARTRIDGE OIL FILTER 0.9900
310 16414-32430 1 CARTRIDGE OIL FILTER 0.9900
310 HH164-32430 1 CARTRIDGE OIL FILTER 1.1000
320 38240-34660 1 ASSY GEAR CASE H/M 0.7370
330 15296-88130 1 GASKET H/METER UNIT 0.0044
340 15221-88210 4 STUD 0.0110
350 02056-50060 4 NUT 0.0044
360 04512-60060 4 WASHER SPRING 0.0022
 F2803-ELA FOR M4900
8 ENGINE 8
000501 HEAD COVER [OLD TYPE] ## S.No.<=3U0371

ITEM PART QTY PART NAME WGT. REMARK S/N

010 15521-05140 1 PLATE B/THER ELEMENT 0.0110
020 15521-05150 1 PLATE B/THER ELEMENT 0.0220
030 15521-05670 1 ELEMENT BREATHER 0.0220
040 15521-05370 1 OIL SHIELD BREATHER 0.0110
050 03034-50510 2 SCREW WITH WASHER 0.0066
060 15521-05550 1 JOINT BREATHER PIPE 0.0880
070 16484-14510 1 COVER CYL.HEAD 3.7400
080 17381-14520 1 GASKET HEAD COVER 0.1100
090 15451-92330 5 NUT 0.0176
100 15021-33660 5 GASKET 0.0022
110 15837-05510 1 PIPE BREATHER 0.1320
 F2803-ELA FOR M4900
9 ENGINE 9
000502 HEAD COVER [NEW TYPE] ## S.No.>=3W0001

ITEM PART QTY PART NAME WGT. REMARK S/N

010 1G837-14510 1 COVER CYL.HEAD 3.4540
020 17381-14520 1 GASKET HEAD COVER 0.1100
030 17182-05020 1 COMP.BREATHER 0.7040
040 17114-05130 2 GASKET BREATHER 0.0044
050 01123-50840 2 BOLT 0.0396
060 16241-05670 1 ELEMENT BREATHER 0.0220
070 17182-14490 1 PLATE 0.1430
080 15451-92330 5 NUT 0.0176
090 15021-33660 5 GASKET 0.0022
100 17182-05510 1 TUBE BREATHER 0.0770
110 09318-88200 2 CLAMP HOSE 0.0088
 F2803-ELA FOR M4900
10 ENGINE 10
010000 MAIN BEARING CASE

ITEM PART QTY PART NAME WGT. REMARK S/N

010 19013-07090 1 ASSY BRG.CASE WHEEL 3.4100
020 19013-04540 2 BOLT BEARING CASE 0.0836
030 19077-04360 1 GASKET BEARING CASE 0.0088 <=3K1872
030 1A091-04362 1 GASKET BEARING CASE 0.0506 =>3L0446
040 19013-04813 1 COVER BEARING CASE 0.9020 <=3Q9655
040 1G851-04810 1 COVER BEARING CASE 1.0890 =>3S0001
040 1G851-04812 1 COVER BEARING CASE 1.0890 =>5A0001
040 1G851-04813 1 COVER BEARING CASE 1.0890 =>6N0001
050 17118-04830 1 GASKET BRG.CASE COV. 0.0220
050 1A091-04820 1 GASKET CASE COVER 0.0220
060 01123-50825 8 BOLT 0.0286
070 01123-50828 8 BOLT 0.0308
080 17381-04460 1 SEAL OIL 0.0990
090 19013-07040 1 ASSY BRG.CASE MAIN 3.3000
100 19013-04540 2 BOLT BEARING CASE 0.0836
110 19013-07050 1 ASSY BRG.CASE MAIN 3.2890
120 19013-04540 2 BOLT BEARING CASE 0.0836
130 19013-07060 1 ASSY BRG.CASE MAIN 3.3440
140 19013-04540 2 BOLT BEARING CASE 0.0836
150 17121-04060 1 ASSY CASE MAIN BRG. 3.4100
160 19013-04540 2 BOLT BEARING CASE 0.0836
170 15601-04560 4 BOLT BEARING CASE 0.1320
 F2803-ELA FOR M4900
11 ENGINE 11
010100 CAMSHAFT AND IDLE GEAR SHAFT

ITEM PART QTY PART NAME WGT. REMARK S/N

010 15601-15550 10 TAPPET 0.1760
020 19013-15110 10 PUSH ROD 0.1100
030 17381-16010 1 ASSY CAMSHAFT 7.8540
040 17381-16150 1 CAMSHAFT 5.7200
050 15521-93610 1 SCREW SET 0.0044
060 15601-93620 1 SCREW SET 0.0550
070 15221-16510 1 GEAR CAM 1.8700 <=1Y8640
070 1A091-16510 1 GEAR CAM 1.7600 =>2A0402
070 1A091-16513 1 GEAR CAM 1.7600 =>3G0430
080 05712-00720 1 KEY FEATHER 0.0176
090 15221-16270 1 STOPPER CAMSHAFT 0.1606
110 01123-50818 2 BOLT 0.0264
120 16478-24012 1 COMP.GEAR IDLE 0.0000 <=1Q7998
120 1A021-24010 1 COMP.GEAR IDLE 2.7280 =>1S0344
120 1A091-24010 1 COMP.GEAR IDLE 2.6620 =>2A0402
130 16427-24980 1 BUSH IDLE GEAR 0.1540 <=1Q7998
130 1A021-24980 1 BUSH IDLE GEAR 0.1584 =>1S0344
140 16427-24360 1 COLLAR 0.0440 <=1Q7998
140 1A021-24370 1 COLLAR 0.0484 =>1S0344
160 15451-95400 1 CIR CLIP EXTERNAL 0.0220
170 16427-24250 1 SHAFT IDLE GEAR 1.4300 <=1Q7998
170 1A021-24250 1 SHAFT IDLE GEAR 1.5070 =>1S0344
170 1A021-24252 1 SHAFT IDLE GEAR 1.5070 =>4W0001
180 01123-50818 3 BOLT 0.0264
 F2803-ELA FOR M4900
12 ENGINE 12
010200 PISTON AND CRANKSHAFT ## NOTE:ORDER BY REF.No.010 and 040 NEW PARTS.

ITEM PART QTY PART NAME WGT. REMARK S/N

010 19077-21110 5 PISTON 1.2760 STD SEE NOTE <=4N0340
010 H1900-21100 5 PISTON 1.2760 STD SEE NOTE <=4N0340
010 19077-21112 5 PISTON 1.2760 STD =>4Q0001
010 19077-21910 5 PISTON 1.2870 +0.5mm SEE NOTE <=4N0340
010 19077-21912 5 PISTON 1.2870 +0.5mm =>4Q0001
020 17331-21050 5 ASSY PISTON RING 0.1430 STD
020 17331-21090 5 ASSY PISTON RING 0.1430 +0.5mm
030 14901-21310 5 PIN PISTON 0.3740
030 1A021-21310 5 PIN PISTON 0.3630
040 14109-21330 10 CIR CLIP INTERNAL 0.0022 <=4N0340
040 1G279-21330 10 CIR CLIP INTERNAL 0.0088 =>4Q0001
050 17311-22010 5 ASSY CONNECTING ROD 1.9470
060 17331-21980 5 BUSH PISTON PIN 0.0550
070 15521-22142 10 BOLT CONNECTING ROD 0.0572
080 17311-22310 5 METAL CRANKPIN 0.0990 STD SET
080 17311-22970 5 METAL CRANKPIN 0.1100 -0.2mm SET
080 17311-22980 5 METAL CRANKPIN 0.0990 -0.4mm SET
090 16449-23010 1 COMP.CRANKSHAFT 45.980
100 07715-00401 5 BALL 0.0022
120 17381-23280 1 SLEEVE CRANKSHAFT 0.1980
130 15601-24110 1 GEAR CRANK 0.7480
140 05712-00730 1 KEY FEATHER 0.0242
150 15401-35630 1 GEAR OIL PUMP DRIVE 0.4070
160 15401-23312 1 SLINGER OIL 0.0220
170 17381-23250 1 COLLAR CRANKSHAFT 0.1540
180 04811-10300 1 O RING 0.0022
 F2803-ELA FOR M4900
12 ENGINE 12
010200 PISTON AND CRANKSHAFT ## NOTE:ORDER BY REF.No.010 and 040 NEW PARTS.
190 17311-23472 1 METAL CRANKSHAFT 0.1320 STD
190 17311-23910 1 METAL CRANKSHAFT 0.1320 -0.2mm
190 17311-23920 1 METAL CRANKSHAFT 0.1320 -0.4mm
200 17311-23480 5 METAL CRANKSHAFT 0.0990 STD SET
200 17311-23930 5 METAL CRANKSHAFT 0.1100 -0.2mm SET
200 17311-23940 5 METAL CRANKSHAFT 0.1320 -0.4mm SET
210 15521-23530 2 METAL SIDE 0.0220 STD
210 15521-23950 2 METAL SIDE 0.0220 +0.2mm
210 15521-23960 2 METAL SIDE 0.0220 +0.4mm
220 19202-23540 2 METAL SIDE 0.0220 STD
220 15221-23970 2 METAL SIDE 0.0198 +0.2mm
220 15221-23980 2 METAL SIDE 0.0198 +0.4mm
230 07916-26940 5 KIT RING PISTON 1.9140 STD ORDER BY REF.No <=4N0340
230 19077-21770 5 KIT PISTON 1.6940 STD =>4Q0001
230 07916-26950 5 KIT RING PISTON 1.9360 +0.5mm ORDER BY REF <=4N0340
230 19077-21780 5 KIT PISTON 1.6280 +0.5mm =>4Q0001
240 07916-28780 1 KIT METAL ENGINE 1.1000 STD
240 07916-28790 1 KIT METAL ENGINE 1.1440 -0.2mm/+0.2mm
240 07916-28800 1 KIT METAL ENGINE 0.3960 -0.4mm/+0.4mm
 F2803-ELA FOR M4900
13 ENGINE 13
010300 FLYWHEEL

ITEM PART QTY PART NAME WGT. REMARK S/N

010 16478-25010 1 COMP.FLYWHEEL 68.200
020 15602-63820 1 GEAR RING 4.8400
030 15321-25163 6 BOLT FLYWHEEL 0.1100
050 16478-04600 1 COMP.HOUSING F-W. 40.040 <=5E0362
050 16478-04602 1 COMP.HOUSING F-W. 40.040 =>5G0001
050 16478-04603 1 COMP.HOUSING F-W. 40.040 =>5U0001
060 05012-01018 2 PIN STRAIGHT 0.0264
070 01073-51250 2 BOLT 0.1210
080 04512-60120 2 WASHER SPRING 0.0110
090 01073-51290 2 BOLT 0.1914
100 01073-51032 11 BOLT 0.0638
110 04512-60100 11 WASHER SPRING 0.0044
120 04512-60120 2 WASHER SPRING 0.0110
130 31220-14170 1 COVER 0.0308
140 01153-50812 1 BOLT 0.0176 <=4Y0300
140 01123-50812 1 BOLT 0.2200 =>5A0001
 F2803-ELA FOR M4900
14 ENGINE 14
010500 FUEL CAMSHAFT

ITEM PART QTY PART NAME WGT. REMARK S/N

010 16484-16170 1 CAMSHAFT FUEL 2.8600
030 08153-06205 1 BEARING BALL 0.2860
040 16415-51150 1 GEAR INJECTION PUMP 2.3650
050 05712-00525 1 KEY FEATHER 0.0110
060 04612-00240 1 CIR CLIP EXTERNAL 0.0044
070 15611-55450 1 SLEEVE GOVERNOR 0.2574
080 15221-55470 1 CIR-CLIP GOV. SLEEVE 0.0066
090 15611-55690 1 CASE GOVERNOR BALL 0.0660
100 07715-03205 39 BALL 0.0022
110 15221-55740 1 CIR-CLIP 0.0044
120 07715-00403 7 BALL 0.0660
130 08240-00001 1 BEARING BALL 0.4400 <=2Z1576
130 19077-97300 1 BEARING BALL 0.3850 =>3A0001
140 15221-16320 1 STOPPER FUEL C/SHAFT 0.0660
150 01153-50814 2 BOLT 0.0198 <=4Y0300
150 01123-60814 2 BOLT 0.0220 =>5A0001
 F2803-ELA FOR M4900
15 ENGINE 15
020000 ENGINE STOP LEVER

ITEM PART QTY PART NAME WGT. REMARK S/N

010 15401-01930 1 COVER 0.1980
020 15625-05430 1 GASKET COVER NA 0.0044
030 01023-50616 2 BOLT 0.0132
040 15521-54090 1 APPARATUS IDLING 0.0990
050 15521-54100 1 ASSY BOLT ADJUSTMENT 0.0330 <=4G0347
050 15521-54103 1 ASSY BOLT ADJUSTMENT 0.0330 =>4J0001
060 15401-92010 1 NUT 0.0220
070 15521-92330 1 NUT 0.0440
080 15021-33660 2 GASKET 0.0022
090 15521-54270 1 CAP 0.0066
100 17331-57702 1 ASSY LEVER ENG.STOP 0.4180 <=5S0336
100 17331-57705 1 ASSY LEVER ENG.STOP 0.4180 =>5U0001
110 15471-51652 1 COVER INJECTION PUMP 0.0440
120 17331-57740 1 SHAFT LEVER 0.0880
130 17331-57720 1 LEVER ENGINE STOP 0.1100
140 15471-57980 1 SEAL OIL 0.0022 <=5S0336
140 16691-57980 1 SEAL OIL 0.0022 =>5U0001
150 05411-00420 1 PIN SPRING 0.0022
160 15471-57920 1 SPRING RETURN 0.0110
170 15296-51660 1 GASKET PUMP COVER 0.0066
170 1A021-51660 1 GASKET PUMP COVER 0.0066
180 01023-50618 1 BOLT 0.0132
190 01023-50622 2 BOLT 0.0110
200 04012-50060 2 WASHER PLAIN 0.0022
210 17394-60110 1 SUPPORT SOLENOID 0.6160 <=4J0372
210 17394-60113 1 SUPPORT SOLENOID 0.6160 =>4N0001
 F2803-ELA FOR M4900
15 ENGINE 15
020000 ENGINE STOP LEVER
210 17394-60114 1 SUPPORT SOLENOID 0.6160 =>5A0001
 F2803-ELA FOR M4900
16 ENGINE 16
020200 INJECTION PUMP

ITEM PART QTY PART NAME WGT. REMARK S/N

010 15401-95690 1 JOINT EYE 0.0880
020 1G833-51010 1 ASSY PUMP INJECTION 6.6660
023 15471-51320 1 SCREW HOLLOW 0.0704
025 15401-96650 2 GASKET 0.0022
030 16484-52090 1 SHIM INJECTION PUMP 0.0154 0.20mm
030 16484-52110 1 SHIM INJECTION PUMP 0.0198 0.25mm
030 16484-52120 1 SHIM INJECTION PUMP 0.0264 0.30mm
040 01123-50822 4 BOLT 0.0264
050 01513-50822 2 STUD 0.0220 <=1Y8640
050 15221-91530 2 STUD 0.0242 =>2A0402
060 02156-50080 2 NUT 0.0088
070 04512-60080 2 WASHER SPRING 0.0044
080 15748-60570 1 ASSY ORIFICE 0.0440
090 17121-52030 1 ASSY PUMP FUEL 0.2860
100 15263-52140 1 GASKET FUEL PUMP 0.0022 <=1S7650
100 1A021-52140 1 GASKET FUEL PUMP 0.0022 =>1U0321
110 16245-91540 2 STUD 0.0110
120 02056-50060 2 NUT 0.0044
130 04512-60060 2 WASHER SPRING 0.0022
140 04012-50060 2 WASHER PLAIN 0.0022
150 32400-35510 1 ASSY PIPE FUEL 0.0770
160 14301-42750 2 CLIP PIPE 0.0110
 F2803-ELA FOR M4900
17 ENGINE 17
020400 GOVERNOR

ITEM PART QTY PART NAME WGT. REMARK S/N

010 15601-56020 1 COMP.LEVER GOVERNOR 0.1210
020 16459-56050 1 ASSY LEVER FORK 0.8844
040 17331-56130 1 LEVER FORK 0.1430
050 15221-56150 1 SHAFT FORK LEVER 0.1210 <=1Y8640
050 1G911-56150 1 SHAFT FORK LEVER 0.1100 =>2A0402
060 15021-56240 1 BOLT LEVER SHAFT 0.0110 <=1Y8640
060 01754-50618 1 BOLT FLANGE 0.0220 =>2A0402
070 04512-60060 2 WASHER SPRING 0.0022 <=1Y8640
070 04512-60060 1 WASHER SPRING 0.0022 =>2A0402
080 15221-56230 1 HOLDER FORK LEVER 0.2200
090 15221-66410 1 BOLT 0.0110
100 01123-50832 2 BOLT 0.0352
110 01023-50628 1 BOLT 0.0330
120 04012-50080 2 WASHER PLAIN 0.0022
130 04012-50060 1 WASHER PLAIN 0.0022
140 15611-56480 1 SPRING START 0.0022
150 19077-56412 1 SPRING 0.0220
160 16415-56420 1 SPRING GOVERNOR 0.0044
 F2803-ELA FOR M4900
18 ENGINE 18
020500 SPEED CONTROL PLATE

ITEM PART QTY PART NAME WGT. REMARK S/N

005 1A021-54350 1 ASSY BOLT ADJUSTMENT 0.0330 =>4G0001
010 15601-54120 1 BOLT ADJUSTING 0.0242 <=4E0364
010 1A021-54120 1 BOLT ADJUSTING 0.0198 =>4G0001
020 15601-92012 1 NUT 0.0132
030 15601-96650 2 GASKET 0.0022
040 15841-14620 1 NUT 0.0132
050 99999-99999 1 PIPE LOCK 0.0000
060 15469-57150 1 LEVER SPEED CONTROL 0.1320
070 05712-00408 1 KEY FEATHER 0.0022
080 04811-00120 1 O RING 0.0022
080 04817-00120 1 O RING 0.0022
090 04013-60080 1 WASHER PLAIN 0.0044
100 02112-50080 2 NUT 0.0066
110 15521-57240 1 COLLAR 0.0044
120 15521-57115 1 PLATE SPEED CONTROL 0.2200
130 15439-57210 1 GASKET 0.0110 <=5Q0355
130 1E147-57210 1 GASKET PLATE 0.0088 =>5S0001
140 01023-50625 2 BOLT 0.0154
150 15221-88210 2 STUD 0.0110
160 04512-60060 2 WASHER SPRING 0.0022
170 02056-50060 2 NUT 0.0044
 F2803-ELA FOR M4900
19 ENGINE 19
020600 NOZZLE HOLDER AND GLOW PLUG

ITEM PART QTY PART NAME WGT. REMARK S/N

010 16454-53900 5 KIT HOLDER NOZZLE 0.2970
020 15841-53622 5 GASKET 0.0044
030 19077-53650 5 SEAL HEAT 0.0044
040 16484-53710 1 PIPE INJECTION 0.3146
050 16484-53720 1 PIPE INJECTION 0.3146
060 16484-53730 1 PIPE INJECTION 0.3146
070 16484-53740 1 PIPE INJECTION 0.3212
080 16484-53750 1 PIPE INJECTION 0.3212
090 15841-53850 6 CLAMP PIPE 0.0176
100 15841-53860 6 CLAMP PIPE 0.0176
110 03024-50520 6 SCREW WITH WASHER 0.0088
120 19077-65510 5 GLOW PLUG 0.0550
130 16415-65560 2 CORD GLOW PLUG 0.0330
130 1G742-65560 2 CORD GLOW PLUG 0.0330
140 16484-42502 1 ASSY PIPE OVER FLOW 0.1760
150 3A011-04490 1 ASSY TUBE FUEL 0.0990
160 09661-40575 1 TUBE FUEL 0.0682
170 14971-42750 2 CLIP PIPE 0.0022
180 02761-50040 5 NUT FLANGE 0.0044
 F2803-ELA FOR M4900
20 ENGINE 20
020700 NOZZLE HOLDER [COMPONENT PARTS]

ITEM PART QTY PART NAME WGT. REMARK S/N

010 16454-53900 5 KIT HOLDER NOZZLE 0.2970
020 15841-92030 5 NUT 0.0110
030 15841-53230 5 WASHER ADJUSTING 0.0022
040 16475-53170 5 SPRING NOZZLE 0.0110
050 15841-53350 5 PIECE DISTANCE 0.0088
060 15841-53160 5 PUSH ROD 0.0022
070 16475-53280 5 NUT NOZZLE 0.0660
080 15841-94040 5 WASHER 0.0022
090 16454-53610 5 PIECE NOZZLE 0.0528
100 15841-98100 5 ASSY WASHER ADJUST 0.0946 OPTION
110 15841-53230 5 WASHER ADJUSTING 0.0022 0.900mm
110 15841-98510 5 WASHER ADJUSTING 0.0022 0.925mm
110 15841-98520 5 WASHER ADJUSTING 0.0022 0.950mm
110 15841-98530 5 WASHER ADJUSTING 0.0022 0.975mm
110 15841-98540 5 WASHER ADJUSTING 0.0022 1.000mm
110 15841-98550 5 WASHER ADJUSTING 0.0022 1.025mm
110 15841-98560 5 WASHER ADJUSTING 0.0022 1.050mm
110 15841-98570 5 WASHER ADJUSTING 0.0022 1.075mm
110 15841-98580 5 WASHER ADJUSTING 0.0022 1.100mm
110 15841-98590 5 WASHER ADJUSTING 0.0022 1.125mm
110 15841-98600 5 WASHER ADJUSTING 0.0022 1.150mm
110 15841-98610 5 WASHER ADJUSTING 0.0022 1.175mm
110 15841-98620 5 WASHER ADJUSTING 0.0022 1.200mm
110 15841-98630 5 WASHER ADJUSTING 0.0022 1.225mm
110 15841-98640 5 WASHER ADJUSTING 0.0022 1.250mm
110 15841-98650 5 WASHER ADJUSTING 0.0022 1.275mm
110 15841-98660 5 WASHER ADJUSTING 0.0022 1.300mm
 F2803-ELA FOR M4900
20 ENGINE 20
020700 NOZZLE HOLDER [COMPONENT PARTS]
110 15841-98670 5 WASHER ADJUSTING 0.0022 1.325mm
110 15841-98680 5 WASHER ADJUSTING 0.0022 1.350mm
110 15841-98690 5 WASHER ADJUSTING 0.0022 1.375mm
110 15841-98700 5 WASHER ADJUSTING 0.0022 1.400mm
110 15841-98710 5 WASHER ADJUSTING 0.0022 1.425mm
110 15841-98720 5 WASHER ADJUSTING 0.0022 1.450mm
110 15841-98730 5 WASHER ADJUSTING 0.0022 1.475mm
110 15841-98740 5 WASHER ADJUSTING 0.0022 1.500mm
110 15841-98750 5 WASHER ADJUSTING 0.0022 1.525mm
110 15841-98760 5 WASHER ADJUSTING 0.0022 1.550mm
110 15841-98770 5 WASHER ADJUSTING 0.0022 1.575mm
110 15841-98780 5 WASHER ADJUSTING 0.0044 1.600mm
110 15841-98790 5 WASHER ADJUSTING 0.0022 1.625mm
110 15841-98800 5 WASHER ADJUSTING 0.0022 1.650mm
110 15841-98810 5 WASHER ADJUSTING 0.0088 1.675mm
110 15841-98820 5 WASHER ADJUSTING 0.0022 1.700mm
110 15841-98830 5 WASHER ADJUSTING 0.0022 1.725mm
110 15841-98840 5 WASHER ADJUSTING 0.0022 1.750mm
110 15841-98850 5 WASHER ADJUSTING 0.0022 1.775mm
110 15841-98860 5 WASHER ADJUSTING 0.0022 1.800mm
110 15841-98870 5 WASHER ADJUSTING 0.0022 1.825mm
110 15841-98880 5 WASHER ADJUSTING 0.0022 1.850mm
110 15841-98890 5 WASHER ADJUSTING 0.0022 1.875mm
110 15841-98900 5 WASHER ADJUSTING 0.0022 1.900mm
110 15841-98910 5 WASHER ADJUSTING 0.0022 1.925mm
110 15841-98920 5 WASHER ADJUSTING 0.0022 1.950mm
120 15841-53622 5 GASKET 0.0044
130 19077-53650 5 SEAL HEAT 0.0044
 F2803-ELA FOR M4900
21 ENGINE 21
050000 WATER FLANGE AND THERMOSTAT

ITEM PART QTY PART NAME WGT. REMARK S/N

010 16415-72702 1 COMP.FLANGE WATER 0.7700
020 17331-73342 1 PIPE WATER RETURN 0.0220
025 15109-33630 1 PLUG DRAIN 0.0550
026 15109-33660 1 GASKET 0.0022
030 15766-72920 1 GASKET WATER FLANGE 0.0220
040 01123-50820 2 BOLT 0.0242
050 01513-50822 1 STUD 0.0220
050 15221-91530 1 STUD 0.0242
060 01153-50870 1 BOLT 0.0572
070 02156-50080 1 NUT 0.0088
080 04512-60080 2 WASHER SPRING 0.0044
090 15521-73340 1 PIPE WATER RETURN 0.0550
090 1G369-73340 1 PIPE WATER RETURN 0.0462
100 15109-73360 2 BAND PIPE 0.0220
110 15321-73260 1 COVER THERMOSTAT 0.2354
120 16221-73270 1 GASKET THERMOSTAT 0.0022
130 01123-50835 2 BOLT 0.0440
140 19434-73010 1 ASSY THERMOSTAT 0.1540 <=1D1169
140 19434-73014 1 ASSY THERMOSTAT 0.1540 =>1E0476
 F2803-ELA FOR M4900
22 ENGINE 22
050100 WATER PUMP

ITEM PART QTY PART NAME WGT. REMARK S/N

010 16412-73030 1 ASSY PUMP WATER 2.6620 <=1W7112
010 1A021-73030 1 ASSY PUMP WATER 2.2000 =>1Y0328
020 17331-73410 1 BODY WATER PUMP 1.1220
030 15521-73550 1 BEARING 0.5170
040 16661-73510 1 IMPELLER WATER PUMP 0.4290 <=1W7112
040 1A021-73510 1 IMPELLER WATER PUMP 0.1430 =>1Y0328
050 16661-73050 1 ASSY SEAL MECHANICAL 0.0550
060 15521-73520 1 FLANGE WATER PUMP 0.5500
070 17326-73430 1 GASKET WATER PUMP 0.0220
080 01123-50828 2 BOLT 0.0308
090 01518-50822 2 STUD 0.0264
100 04512-60080 2 WASHER SPRING 0.0044
110 02156-50080 2 NUT 0.0088
120 15221-88210 1 STUD 0.0110
130 01023-50618 8 BOLT 0.0132
140 02056-50060 1 NUT 0.0044
150 04512-60060 1 WASHER SPRING 0.0022
 F2803-ELA FOR M4900
23 ENGINE 23
060000 VALVE AND ROCKER ARM

ITEM PART QTY PART NAME WGT. REMARK S/N

010 16484-13110 5 VALVE INLET 0.1320
020 16484-13120 5 VALVE EXHAUST 0.1650
030 15221-13240 10 SPRING VALVE 0.0836
040 15221-13330 10 RETAINER VALVE SP. 0.0616
050 15221-13360 10 COLLET VALVE SPRING 0.0110 SET
050 15221-13980 10 COLLET VALVE SPRING 0.0110 SET
060 15221-13150 10 SEAL VALVE STEM 0.0022 <=3W0499
060 15221-13153 10 SEAL VALVE STEM 0.0044 =>3Y0001
070 15221-13280 10 CAP VALVE 0.0110
080 17381-14052 1 ASSY SHAFT R-ARM 1.3200
090 03410-50808 2 SCREW SET 0.0044
100 15221-14350 5 BRACKET ROCKER ARM 0.0968 <=4U0296
100 15221-14353 5 BRACKET ROCKER ARM 0.0968 =>4W0001
110 15521-91500 5 STUD 0.0770
120 02156-50080 5 NUT 0.0088
130 04512-60080 5 WASHER SPRING 0.0044
140 04012-50080 5 WASHER PLAIN 0.0022
150 05411-00528 1 PIN SPRING 0.0066
160 15221-14430 2 WASHER R-ARM.SHAFT 0.0044
170 15221-14310 4 SPRING ROCKER ARM 0.0110
180 04612-00140 2 CIR CLIP EXTERNAL 0.0022
190 15621-14030 10 ASSY ROCKER ARM 0.2200
210 15521-14230 10 SCREW ADJUSTING 0.0198
220 15021-14240 10 NUT 0.0066
 F2803-ELA FOR M4900
24 ENGINE 24
060100 INLET MANIFOLD

ITEM PART QTY PART NAME WGT. REMARK S/N

010 16459-11760 1 MANIFOLD INLET 3.3000 <=3U0371
010 19279-11800 1 COMP MANIFOLD INLET 3.6300 =>3W0001
015 17182-05550 1 JOINT BREATHER 0.0330 =>3W0001
020 17394-11820 1 GASKET IN-MANIFOLUDO 0.0462
030 01123-50822 9 BOLT 0.0264
 F2803-ELA FOR M4900
25 ENGINE 25
060200 EXHAUST MANIFOLD

ITEM PART QTY PART NAME WGT. REMARK S/N

010 17393-12310 1 MANIFOLD EXHAUST 7.4800
020 15439-12350 1 GASKET EX-MANIFOLD 0.0440
020 1A091-12360 1 GASKET EX-MANIFOLD 0.0440
030 15313-12350 1 GASKET EX-MANIFOLD 0.0880
030 1A021-12350 1 GASKET EX-MANIFOLD 0.0616
040 02156-50080 10 NUT 0.0088
050 04512-60080 10 WASHER SPRING 0.0044
060 15221-91530 10 STUD 0.0242
 F2803-ELA FOR M4900
26 ENGINE 26
060300 AIR CLEANER

ITEM PART QTY PART NAME WGT. REMARK S/N

010 3A011-19100 1 ASSY CLEANER AIR 3.8940
020 01123-50820 2 BOLT 0.0242
030 3A011-17310 1 HOSE INLET 2.1230
040 31351-18110 1 BAND PIPE 0.0880
050 68811-42270 1 BAND PIPE 0.0880
050 35466-74460 1 BAND PIPE 0.0836
060 3A211-19110 1 SUPPORT AIR CLEANER 8.8000
070 01133-51025 4 BOLT 0.0506
 F2803-ELA FOR M4900
27 ENGINE 27
060400 AIR CLEANER [COMPONENT PARTS]

ITEM PART QTY PART NAME WGT. REMARK S/N

010 3A011-19100 1 ASSY CLEANER AIR 3.8940
020 3A011-19120 1 BODY AIR CLEANER 1.4740
030 R2401-42280 1 ELEMENT INNER 0.6600
040 R1401-42270 1 ELEMENT OUTER 1.1000
050 R1401-42260 1 CUP DUST 0.6600
060 R1401-42290 1 VALVE EVACUATOR 0.0220
 F2803-ELA FOR M4900
28 ENGINE 28
060701 MUFFLER [EXCEPT [CS]]

ITEM PART QTY PART NAME WGT. REMARK S/N

010 3A011-12110 1 MUFFLER 0.0000
020 3A011-12130 1 ASSY BAND MUFFLER 9.9000
040 3A011-12140 1 ASSY BAND PIPE 2.1780
050 15616-12320 1 FLANGE MUFFLER 2.8600
050 3A211-12310 1 FLANGE MUFFLER 3.0360
060 01517-61030 2 STUD 0.0462
070 3A011-12180 2 NUT 0.0264
080 04512-60100 2 WASHER SPRING 0.0044
090 3A011-12150 1 COVER MUFFLER 1.8920
100 3A011-12160 4 NUT FLANGE 0.0198
110 15625-12360 1 GASKET MUFFLER FLANG 0.0220
120 3A011-12170 1 COVER MUFFLER 0.5940
 F2803-ELA FOR M4900
29 ENGINE 29
060702 UNDER MUFFLER [CS]

ITEM PART QTY PART NAME WGT. REMARK S/N

010 3A011-12110 1 MUFFLER 0.0000
020 3A011-12130 1 ASSY BAND MUFFLER 9.9000
030 3A011-12140 1 ASSY BAND PIPE 2.1780
040 3A011-12310 1 PIPE UNDER MUFFLER 0.0000
050 3A011-12320 1 STAY UNDER MUFFLER 0.8580
060 3A011-12330 1 PIPE UNDER MUFFLER 0.0000
070 01517-61030 2 STUD 0.0462
080 3A011-12180 2 NUT 0.0264
090 04512-60100 2 WASHER SPRING 0.0044
100 15625-12360 1 GASKET MUFFLER FLANG 0.0220
110 3A011-12150 1 COVER MUFFLER 1.8920
120 3A011-12160 4 NUT FLANGE 0.0198
 F2803-ELA FOR M4900
30 ENGINE 30
090600 UPPER GASKET KIT

ITEM PART QTY PART NAME WGT. REMARK S/N

010 07916-27806 1 KIT GASKET UPPER 1.1000 <=3W0499
010 07916-27807 1 KIT GASKET UPPER 1.1000 =>3Y0001
020 04811-50300 1 O RING 0.0022
020 04817-50300 1 O RING 0.0022
030 15625-12360 1 GASKET MUFFLER FLANG 0.0220
040 15021-33660 5 GASKET 0.0022
050 15221-13150 10 SEAL VALVE STEM 0.0022 <=3W0499
050 15221-13153 10 SEAL VALVE STEM 0.0044 =>3Y0001
060 15221-33700 1 O RING 0.0022
070 16221-73270 1 GASKET THERMOSTAT 0.0022
080 15109-33660 1 GASKET 0.0022
090 15766-72920 1 GASKET WATER FLANGE 0.0220
090 1A021-72920 1 GASKET WATER FLANGE 0.0044
100 17394-11820 1 GASKET IN-MANIFOLUDO 0.0462
110 17381-14520 1 GASKET HEAD COVER 0.1100
120 16484-03310 1 GASKET CYLINDER HEAD 0.3080
130 15313-12350 1 GASKET EX-MANIFOLD 0.0880
130 1A021-12350 1 GASKET EX-MANIFOLD 0.0616
140 15439-12350 1 GASKET EX-MANIFOLD 0.0440
140 1A091-12360 1 GASKET EX-MANIFOLD 0.0440
150 15625-32890 1 GASKET 0.0022
160 15841-53622 5 GASKET 0.0044
170 19077-53650 5 SEAL HEAT 0.0044
180 1C011-12230 1 GASKET MUFFLER 0.0308 OUT OF USE
190 17383-12380 1 GASKET MUFFLER FLAN. 0.0286 OUT OF USE
 F2803-ELA FOR M4900
31 ENGINE 31
090700 LOWER GASKET KIT

ITEM PART QTY PART NAME WGT. REMARK S/N

010 07916-27826 1 KIT GASKET LOWER 0.8800 <=3K1872
010 07916-27827 1 KIT GASKET LOWER 0.8800 =>3L0466
020 04811-00120 1 O RING 0.0022
020 04817-00120 1 O RING 0.0022
030 04811-00150 3 O RING 0.0022
030 04817-00150 3 O RING 0.0022
040 04811-00180 1 O RING 0.0022
040 04817-00180 1 O RING 0.0022
050 04811-00360 1 O RING 0.0044
050 04817-00360 1 O RING 0.0022
060 04811-10300 1 O RING 0.0022
070 19202-04140 1 SEAL OIL 0.0330
080 15021-33660 3 GASKET 0.0022
090 6C090-58960 2 GASKET 0.0110
100 17118-04830 1 GASKET BRG.CASE COV. 0.0220
100 1A091-04820 1 GASKET CASE COVER 0.0220
110 15625-05430 1 GASKET COVER NA 0.0044
120 15296-35150 1 GASKET OIL PUMP 0.0022
120 1A021-35150 1 GASKET OIL PUMP 0.0022
130 15296-51660 1 GASKET PUMP COVER 0.0066
130 1A021-51660 1 GASKET PUMP COVER 0.0066
140 15296-88130 1 GASKET H/METER UNIT 0.0044
150 15263-52140 1 GASKET FUEL PUMP 0.0022
150 1A021-52140 1 GASKET FUEL PUMP 0.0022
160 15471-57980 1 SEAL OIL 0.0022
170 15766-73330 1 GASKET WATER FLANGE 0.0044
 F2803-ELA FOR M4900
31 ENGINE 31
090700 LOWER GASKET KIT
170 1A021-73330 1 GASKET RETURN FLANGE 0.0022
180 15601-96650 2 GASKET 0.0022
190 17326-04132 1 GASKET GEAR CASE 0.0660
200 17326-32620 1 GASKET 0.0110
210 15439-57210 1 GASKET 0.0110
220 17326-73430 1 GASKET WATER PUMP 0.0220
220 1A021-73430 1 GASKET WATER PUMP 0.0154
230 16478-01620 1 GASKET OIL PAN 0.0572
240 19077-04360 1 GASKET BEARING CASE 0.0088 <=3K1872
240 1A091-04362 1 GASKET BEARING CASE 0.0506 =>3L0446
250 19202-96830 1 O RING 0.0220
260 04811-00200 1 O RING 0.0022
260 04817-00200 1 O RING 0.0242
270 17381-04460 1 SEAL OIL 0.0990
280 15401-96650 2 GASKET 0.0022
290 17121-01620 1 GASKET OIL PAN 0.0616 OUT OF USE
300 15451-96670 1 GASKET 0.0066 OUT OF USE
310 15109-33660 2 GASKET 0.0022 OUT OF USE
 F2803-ELA FOR M4900
32 FUEL SYSTEM 32
A11000 FUEL TANK

ITEM PART QTY PART NAME WGT. REMARK S/N

010 3A011-04110 1 TANK FUEL 11.220 <=13405
010 3A011-04113 1 TANK FUEL 11.220 =>13406
020 3A011-97373 1 KIT CAP FUEL TANK 0.1100
030 6C040-47412 1 LABEL FILLER CAUTION 0.0022
040 34150-35240 1 SPONGE 0.0022
050 3A011-04300 1 GASKET 0.0330
060 34150-35180 1 GASKET 0.0022
070 13582-41680 1 PLATE F.TANK.CAP 0.0176
080 3A011-04232 6 CUSHION 0.0220
080 3A272-04230 6 CUSHION 0.1540
090 3A011-04222 2 CUSHION 0.0880
100 3A011-04210 2 CUSHION 0.2310
110 3A011-04520 1 BASE FUEL TANK 4.4330
120 01133-51225 2 BOLT 0.0770
130 3A011-04515 1 SUPPORT FUEL TANK 13.530
130 3A011-04516 1 SUPPORT FUEL TANK 13.530 <=13405
130 3A011-04517 1 SUPPORT FUEL TANK 13.530 =>13406
140 3A011-04530 1 STAY FUEL TANK 0.9240
150 01125-60820 2 BOLT 0.0330
160 01133-51025 2 BOLT 0.0506 <=12064
160 01135-61025 2 BOLT 0.0594 =>12065
180 01754-50816 1 BOLT FLANGE 0.0242
190 3A011-04130 2 CLAMP 1.1880
200 02552-50080 4 NUT LOCK 0.0110
210 04013-60080 4 WASHER PLAIN 0.0044
220 3A011-04570 1 SPONGE TANK REAR 0.1232
 F2803-ELA FOR M4900
32 FUEL SYSTEM 32
A11000 FUEL TANK
230 38430-29670 1 CUSHION 0.0220
240 3A011-04320 1 INSULATION HEAT 0.6600 <=13405
240 3A011-04322 1 INSULATION HEAT 0.6600 =>13406
250 3A011-04610 1 PLATE SHUTTER 1.3640 <=12974
250 3A011-04613 1 PLATE SHUTTER 1.3640 =>12975
260 01754-50616 4 BOLT FLANGE 0.0132
270 35533-04750 1 RING RUBBER 0.0044 <=12983
270 TA470-38290 1 TRIM 0.0110 =>12984
280 12234-67580 1 CLAMP CORD 0.0264
 F2803-ELA FOR M4900
33 FUEL SYSTEM 33
A17000 FUEL FILTER

ITEM PART QTY PART NAME WGT. REMARK S/N

010 34550-42612 1 ASSY TUBE FUEL 0.1584
010 34550-42650 1 ASSY TUBE FUEL 0.1320
020 09661-80400 1 TUBE FUEL 0.1100
040 34550-42710 1 TUBE PIPE 0.0330
050 14301-42750 1 CLIP PIPE 0.0110
050 14911-42750 2 CLIP PIPE 0.0044
060 T0070-42610 1 ASSY TUBE FUEL 0.1848
070 09661-80500 1 TUBE FUEL 0.1100
080 14301-42750 2 CLIP PIPE 0.0110
090 T0070-99020 1 TUBE PIPE 0.0264
100 34550-42633 1 ASSY TUBE FUEL 0.1430
110 09661-40900 1 TUBE FUEL 0.0990
120 14971-42750 2 CLIP PIPE 0.0022
130 34070-42633 1 ASSY TUBE FUEL 0.0550
140 09661-40400 1 TUBE FUEL 0.0440
150 14971-42750 2 CLIP PIPE 0.0022
160 3A011-04153 1 TRAY FUEL 0.3080
170 15521-43015 1 ASSY FILTER FUEL 1.2980
170 1A001-43010 1 ASSY FILTER FUEL 1.1440
180 01754-50825 2 BOLT FLANGE 0.0220
190 3A011-04250 1 STAY FUEL FILTER 0.8800
200 01123-50818 2 BOLT 0.0264
 F2803-ELA FOR M4900
34 FUEL SYSTEM 34
A18000 FUEL FILTER [COMPONENT PARTS]

ITEM PART QTY PART NAME WGT. REMARK S/N

010 15521-43015 1 ASSY FILTER FUEL 1.2980
010 1A001-43010 1 ASSY FILTER FUEL 1.1440
020 15521-43114 1 ASSY BODY 0.5170 ORDER BY REF.No.010 <=13710
020 1A001-43110 1 ASSY BODY 0.0000 ORDER BY REF.No.010 =>13711
030 15521-43522 1 HANDLE FILTER 0.0880 <=13710
030 1A001-43520 1 HANDLE FILTER 0.0880 =>13711
040 15521-43672 1 GASKET 0.0044 <=13710
040 1A001-43670 1 GASKET 0.0000 =>13711
050 15521-43552 1 RETAINER HANDLE 0.0220 <=13710
050 1A001-43550 1 RETAINER HANDLE 0.0220 =>13711
060 15521-43542 1 PLATE THRUST 0.0022 <=13710
060 1A001-43540 1 PLATE THRUST 0.0022 =>13711
070 04811-10290 1 O RING 0.0022
080 03054-50308 2 SCREW PAN-HEAD 0.0110
090 15521-43150 1 RING RETAINER 0.3080 <=13710
090 1A001-43150 1 RING RETAINER 0.2860 =>13711
100 15521-43100 1 ASSY CUP FILTER 0.0770 <=13710
100 1A001-43100 1 ASSY CUP FILTER 0.1254 =>13711
105 15521-43130 1 POT FILTER 0.2200
105 1A001-43130 1 CUP FILTER 0.1320
110 16873-88430 1 LABEL FUEL 0.0022 <=13710
110 1A001-88430 1 LABEL FUEL 0.0022 =>13711
120 15521-43160 1 ELEMENT FILTER 0.1540
120 1A001-43160 1 ELEMENT FILTER 0.1650
130 04811-50650 1 O RING 0.0044
140 15521-43930 1 SPRING 0.0088
140 1A001-43930 1 SPRING 0.0066
 F2803-ELA FOR M4900
34 FUEL SYSTEM 34
A18000 FUEL FILTER [COMPONENT PARTS]
150 04811-00160 1 O RING 0.0022
150 04816-00160 1 O RING 0.0066
 F2803-ELA FOR M4900
35 COOLING WATER SYSTEM 35
A41000 FAN

ITEM PART QTY PART NAME WGT. REMARK S/N

010 15601-74110 1 FAN 0.9460
020 3A011-17260 1 FLANGE FAN 0.5060
030 01754-50655 4 BOLT FLANGE 0.0308
040 01754-50612 6 BOLT FLANGE 0.0110
050 15196-97010 1 V BELT A 0.2728
060 17351-74250 1 PULLEY FAN 0.5720
 F2803-ELA FOR M4900
36 COOLING WATER SYSTEM 36
A42000 WATER PIPE

ITEM PART QTY PART NAME WGT. REMARK S/N

010 3A211-17460 1 HOSE WATER UPPER 0.5280
020 09318-89052 2 CLAMP HOSE 0.0660 <=11284
020 15108-72870 2 BAND 0.0594 =>11285
030 3A211-17450 1 HOSE WATER LOWER 0.4950
040 15108-72870 2 BAND 0.0594
050 3A611-17430 1 HOSE WATER RETURN 0.1760
060 68171-63630 2 BAND HOSE 0.0286
 F2803-ELA FOR M4900
37 COOLING WATER SYSTEM 37
A43000 RADIATOR

ITEM PART QTY PART NAME WGT. REMARK S/N

010 3A231-17100 1 ASSY RADIATOR 9.0200
010 H3A20-17100 1 ASSY RADIATOR 9.0200
020 17580-16060 1 CAP RADIATOR 0.0880
030 34070-16070 1 PLUG DRAIN 0.0110
040 34070-16090 1 O RING 0.0022
050 3A211-97350 1 KIT SHROUD FAN(A) 4.6200
060 32751-49580 2 LABEL FAN BELT 0.0022
070 3A111-17290 1 TRIM SASH 0.0132
080 01025-50612 4 BOLT 0.0110
090 3A211-72360 1 HOLDER NET RH 0.4180
100 3A211-72370 1 HOLDER NET LH 0.4180
110 01754-50610 6 BOLT FLANGE 0.0132
120 3A211-17410 1 NET RADIATOR 0.4950
130 3A111-17420 1 NET RADIATOR LOWER 0.4840
140 02810-50060 2 NUT WING 0.0198
150 34070-16030 4 RUBBER 0.0330
160 3A611-17190 2 SPONGE SIDE 0.0440
170 3A211-83050 1 GUIDE LH 0.3300 <=12464
170 3A151-83050 1 GUIDE LH 0.3190 =>12465
180 3A211-83040 1 GUIDE RH 0.3300 <=12464
180 3A151-83040 1 GUIDE RH 0.3190 =>12465
190 01025-50612 4 BOLT 0.0110
 F2803-ELA FOR M4900
38 COOLING WATER SYSTEM 38
A45000 RESERVE TANK

ITEM PART QTY PART NAME WGT. REMARK S/N

010 3A111-17300 1 ASSY TANK RESERVE 0.8360
020 15531-72422 1 CAP 0.0022
030 15531-72432 1 GASKET 0.0044
040 3A111-17320 1 PIPE WATER OVER FLOW 0.1320
050 3A111-17330 1 TUBE WATER 0.1760
060 15501-72470 2 CLIP PIPE 0.0110
065 5H730-25660 1 TUBE 0.0286
070 T0090-63580 2 BAND CORD 0.0110
 F2803-ELA FOR M4900
39 ELECTRICAL SYSTEM 39
A54000 ALTERNATOR

ITEM PART QTY PART NAME WGT. REMARK S/N

010 TA040-74020 1 STAY ALTERNATOR 0.1980
010 16427-64420 1 STAY DYNAMO 0.1760
020 16484-74280 1 PULLEY FAN DRIVE 5.2800
030 17121-91010 1 BOLT 0.5720
040 3A011-74010 1 ALTERNATOR 6.1600 <=12086
040 3A011-74012 1 ALTERNATOR 6.1600 =>12087
040 3A011-74013 1 ALTERNATOR 6.1600 =>13630
050 01173-51003 1 BOLT 0.1694
060 02076-50100 1 NUT 0.0132
070 04512-60100 1 WASHER SPRING 0.0044
080 04013-60100 1 WASHER PLAIN 0.0066
090 01123-50830 1 BOLT 0.0330
100 02056-50060 1 NUT 0.0044 <=12464
100 12264-92020 1 NUT SPRING WASHER M 0.1100 =>12465
 F2803-ELA FOR M4900
40 ELECTRICAL SYSTEM 40
A55000 ALTERNATOR [COMPONENT PARTS]

ITEM PART QTY PART NAME WGT. REMARK S/N

010 3A011-74010 1 ALTERNATOR 6.1600 12V 40A <=12086
010 3A011-74012 1 ALTERNATOR 6.1600 12V 40A =>12087
010 3A011-74013 1 ALTERNATOR 6.1600 12V 40A =>13630
020 16427-64110 1 PULLEY ALTERNATOR 0.4400
030 15881-92010 1 NUT 0.0440
040 15881-64150 1 COLLAR 0.0088
050 66436-64040 1 ROTOR 2.6400
060 15881-64800 1 COVER BEARING 0.0022
070 16652-64770 1 BEARING BALL 0.0990
090 66436-64020 1 ASSY FRAME DRIVE END 2.4200
100 15881-64710 1 PLATE RETAINER 0.0220
110 15881-93010 4 SCREW ROUND HEAD 0.0066
120 15881-64260 2 BOLT THROUGH 0.0220
130 16652-64780 1 BEARING BALL 0.1100
140 16241-64060 1 FRAME END 0.4400
150 16241-64230 1 COVER END 0.0000 <=12086
150 16231-64230 1 COVER END 0.0770 =>12087
160 16241-64850 1 ASSY RECTIFIER 0.3520
170 16241-64900 1 BUSH INSULATION 0.0154
180 16652-64310 1 HOLDER BRUSH 0.0550
190 15881-64090 2 BRUSH 0.0044
200 15881-64330 2 SPRING BRUSH 0.0044
210 15881-93020 2 SCREW ROUND HEAD 0.0110
220 15881-93030 6 SCREW ROUND HEAD 0.0066
230 15881-93040 1 SCREW ROUND HEAD 0.0066
240 15881-91040 3 BOLT 0.0110
 F2803-ELA FOR M4900
40 ELECTRICAL SYSTEM 40
A55000 ALTERNATOR [COMPONENT PARTS]
250 15881-92020 2 NUT 0.0440
260 15881-91050 2 BOLT 0.0220
270 14182-92030 1 NUT 0.0066
280 66436-64600 1 ASSY REGULATOR 0.1760 <=13629
280 1K531-64602 1 ASSY REGULATOR 0.1760 =>13630
 F2803-ELA FOR M4900
41 ELECTRICAL SYSTEM 41
A56000 STARTER

ITEM PART QTY PART NAME WGT. REMARK S/N

010 15621-63012 1 ASSY STARTER 8.5140
020 01517-51028 1 STUD 0.0484
030 02176-50100 1 NUT 0.0110
040 01133-51030 1 BOLT 0.0550
050 04512-60100 1 WASHER SPRING 0.0044
060 16429-92010 1 NUT 0.0154
 F2803-ELA FOR M4900
42 ELECTRICAL SYSTEM 42
A57000 STARTER [COMPONENT PARTS]

ITEM PART QTY PART NAME WGT. REMARK S/N

010 15621-63012 1 ASSY STARTER 8.5140
020 11197-63080 1 ASSY YOKE 2.0240
030 11197-63070 1 ASSY ARMATURE 1.8040
040 11460-63500 1 BEARING 0.0660
050 11460-63530 1 BEARING 0.0440
060 15621-63040 1 CLUTCH OVER RUNNING 1.3200
065 11233-63280 1 GEAR PINION 0.2200
070 16661-63030 1 FRAME DRIVE END 0.9020
080 11173-63020 1 ASSY SWITCH MAGNETIC 0.4400
090 99999-99999 1 BLANK 0.0000
100 17341-63200 1 FRAME END 0.2860
110 11197-63380 1 ASSY HOLDER BRUSH 0.1100
120 15401-63390 4 SPRING BRUSH 0.0066
130 11460-63270 1 GEAR 0.0880
140 11460-63110 1 RETAINER 0.0220
150 19212-63100 5 ROLLER 0.0044
160 19212-97130 1 BALL 0.0066
170 11460-63120 1 SPRING 0.0220
180 11460-93310 2 BOLT 0.0220
190 15511-96660 2 O RING 0.0110
200 15511-63760 2 ASSY BOLT 0.0110
210 16285-63570 1 PIPE DRAIN 0.0110
220 13963-92010 1 NUT HEXAGON 0.0110
230 11197-63320 2 BOLT 0.0440
240 04512-60080 1 WASHER SPRING 0.0044
260 16285-92010 1 NUT HEXAGON 0.0110
 F2803-ELA FOR M4900
42 ELECTRICAL SYSTEM 42
A57000 STARTER [COMPONENT PARTS]
270 11173-63130 1 COVER TERMINAL 0.0154
280 16285-98050 1 ASSY COVER 0.1056
 F2803-ELA FOR M4900
43 ELECTRICAL SYSTEM 43
A58000 BATTERY

ITEM PART QTY PART NAME WGT. REMARK S/N

010 99999-99999 1 BATTERY 0.0000 105E41R [A]
010 99999-99999 1 BATTERY 0.0000 12V CCA700A [CA]
020 3A011-77110 1 CORD BATTERY 1.4630
030 32530-91710 1 CAP RUBBER 0.0220
040 31351-33343 1 CORD EARTH 0.3630
040 TA140-33340 1 CORD EARTH 0.3740 <=12983
040 T1170-30130 1 CORD EARTH 0.2970 =>12984
050 01125-60816 1 BOLT 0.0220 <=11315
050 01754-50814 1 BOLT FLANGE 0.0264 =>11316
060 15272-67590 2 CLAMP CORD 0.0088
070 01023-50612 2 BOLT 0.0110
080 3A211-21730 1 SUPPORT BATTERY 11.440
090 01133-51020 4 BOLT 0.0440
100 3A111-74340 2 CUSHION BATTERY 0.2640
110 36200-81672 1 PLUG 0.0660
120 3A111-74360 2 BOLT HOOK(BATTERY) 0.0704 <=12974
120 3A111-74362 2 BOLT HOOK(BATTERY) 0.0704 =>12975
130 02014-50060 4 NUT 0.0044
140 04015-60060 2 WASHER PLAIN 0.0110
150 36230-74350 1 RETAINER BATTERY 0.7260
150 3A211-74350 1 RETAINER BATTERY 0.7810 <=13932
150 3A211-74352 1 RETAINER BATTERY 0.7810 =>13933
160 38430-29670 2 CUSHION 0.0220
 F2803-ELA FOR M4900
44 ELECTRICAL SYSTEM 44
B01500 SWITCH/SENSOR

ITEM PART QTY PART NAME WGT. REMARK S/N

010 3A011-75302 1 ASSY SENSOR FUEL 0.6600
020 67980-54740 1 GASKET 0.0110
030 04512-60050 5 WASHER SPRING 0.0044
040 02054-50050 5 NUT 0.0044
050 TA040-43900 1 SWITCH LEVER 0.0176
060 03024-50414 1 SCREW WITH WASHER 0.0044
070 3A011-75100 1 SWITCH 0.1056
080 04412-50140 1 WASHER TOOTHED 0.0044
090 3A651-75130 1 SHIM 0.0022 0.5mm
100 3A211-34432 1 STAY SWITCH SHUTTLE 0.2640
110 01754-50816 2 BOLT FLANGE 0.0242
120 3A211-34440 1 COVER SWITCH SHUTTLE 0.2310
130 01754-50612 2 BOLT FLANGE 0.0110
140 15531-39010 1 SWITCH OIL 0.0704
150 31351-32830 1 SENSOR THERMO 0.0440
160 3A272-75250 1 TIMER BUZZER 0.1100 =>13410
170 53660-53810 1 BUZZER BACK 0.0770 =>13410
180 01754-50612 2 BOLT FLANGE 0.0110 =>13410
190 55579-98980 1 RING RUBBER 0.0066 =>13410
200 T1060-30540 1 CLIP 0.0220 =>13410
 F2803-ELA FOR M4900
45 ELECTRICAL SYSTEM 45
B10400 SWITCH(PANEL BOARD)/RELAY

ITEM PART QTY PART NAME WGT. REMARK S/N

010 52200-41212 1 SWITCH STARTER 0.6160
020 3F240-75430 1 UNIT FLASHER 0.1320
030 35593-75210 1 RELAY GLOW PLUG 0.1936
040 36919-75030 1 RELAY 0.0880
040 H3690-75000 1 RELAY 0.0880
050 36919-55830 1 BRACKET RELAY 0.0110
060 35800-75070 1 RELAY STARTER 0.1760
070 01754-50612 6 BOLT FLANGE 0.0110
080 T0070-31410 1 TIMER KEY STOP 0.1430
090 36330-75010 1 SWITCH COMBINATION 0.1980
095 35999-12660 1 NUT RING 0.0330
096 35999-12670 1 LEVER SWITCH 0.0110
097 36330-12690 1 KNOB LIGHT 0.0264
100 37500-55212 1 SWITCH HAZARD 0.0440 <=13932
100 R1401-53262 1 SWITCH HAZARD 0.0440 =>13933
100 3C001-75040 1 SWITCH HAZARD 0.0330 =>13933
110 18510-63720 1 ASSY KEY STARTER 0.0550
 F2803-ELA FOR M4900
46 ELECTRICAL SYSTEM 46
B14000 PANEL BOARD

ITEM PART QTY PART NAME WGT. REMARK S/N

010 3A211-75600 1 ASSY PANEL 6.3800
020 31391-31140 6 SCREW 0.0220
030 31351-18860 6 WASHER 0.0044
040 35533-75610 1 CABLE HOUR METER 0.6600
 F2803-ELA FOR M4900
47 ELECTRICAL SYSTEM 47
B15000 PANEL BOARD [COMPONENT PARTS]

ITEM PART QTY PART NAME WGT. REMARK S/N

010 3A211-75600 1 ASSY PANEL 6.3800
020 3A153-83550 1 BONNET REAR UPPER 3.9710
030 3A011-75660 1 ASSY TACHOMETER 0.5170
040 31351-93720 1 ASSY GAUGE FUEL 0.2750
050 31351-93730 1 ASSY GAUGE TEMP. 0.2860
060 3A011-75670 1 CASE 0.9900
070 31351-93760 1 GLASS WITH GASKET 1.0450
080 34550-30180 1 ADAPTER 0.1100
090 34670-93780 1 ASSY PLATE SUB 0.1100
100 38240-31460 8 ASSY LAMP ELECTRIC 0.0330
110 38240-31470 8 BULB 0.0220 3.4W
120 38240-31480 8 SOCKET 0.0022
130 31351-93790 1 GASKET RUBBER 0.1210
140 31351-93800 1 PLATE WIND 0.3960
150 3A011-75680 1 LENS 0.0330
160 31351-93820 2 LENS 0.0110
170 34670-93830 1 CASE 0.4290
180 31351-93840 1 CASE 0.2860
190 35533-76160 2 SCREW 0.0022
200 35533-76230 6 SCREW WITH WASHER 0.0044
210 03514-50425 6 SCREW TAPPING 0.0022
220 03514-50414 5 SCREW TAPPING 0.0022
230 35533-76170 2 SCREW WITH WASHER 0.0022
240 3A011-75700 1 ASSY PLATE 0.2310
250 03514-50420 11 SCREW 0.0044
260 32530-94690 2 SCREW TAPPING 0.0022
 F2803-ELA FOR M4900
48 ELECTRICAL SYSTEM 48
B32000 HEAD LIGHT

ITEM PART QTY PART NAME WGT. REMARK S/N

010 3A011-75720 1 LIGHT HEAD RH 1.0780
020 38450-33870 1 BULB 0.0550 45W
030 3A011-75740 1 COMP.SOCKET 0.1386
040 3A011-75710 1 LIGHT HEAD LH 0.8580
050 38450-33870 1 BULB 0.0550 45W
060 3A011-75740 1 COMP.SOCKET 0.1386
070 3A011-75860 6 SCREW 0.0132
080 38240-33860 6 SPRING LIGHT 0.0022
 F2803-ELA FOR M4900
49 ELECTRICAL SYSTEM 49
B33501 HAZARD LIGHT/TAIL LIGHT [OLD TYPE] ## S.No.<=12438

ITEM PART QTY PART NAME WGT. REMARK S/N

010 32530-33610 2 ASSY LIGHT HAZARD 0.8360
020 32530-91510 4 LENS HAZARD LIGHT 0.1870
030 32530-91520 12 SCREW TAPPING 0.0022
040 32530-91530 2 BULB LIGHT 0.0440 27W
050 02114-50100 2 NUT 0.0110
060 04411-50100 2 WASHER TOOTHED 0.0022
070 3A011-75880 1 ASSY LIGHT TAIL RH 0.6380
080 32530-91810 1 LENS REAR COMBI. 0.2200
090 32530-91820 1 BULB LIGHT 0.0374 8W
100 32530-91860 1 GASKET 0.0022
110 32530-91840 2 SCREW 0.0110
120 3A011-75890 1 ASSY LIGHT TAIL LH 0.6380
130 32530-91810 1 LENS REAR COMBI. 0.2200
140 32530-91820 1 BULB LIGHT 0.0374 8W
150 32530-91860 1 GASKET 0.0022
160 32530-91840 2 SCREW 0.0110
 F2803-ELA FOR M4900
50 ELECTRICAL SYSTEM 50
B33502 HAZARD LIGHT/TAIL LIGHT [NEW TYPE] ## S.No.>=12439

ITEM PART QTY PART NAME WGT. REMARK S/N

010 32530-33610 2 ASSY LIGHT HAZARD 0.8360
020 32530-91510 4 LENS HAZARD LIGHT 0.1870
030 32530-91520 12 SCREW TAPPING 0.0022
040 32530-91530 2 BULB LIGHT 0.0440 27W
050 02114-50100 2 NUT 0.0110
060 04411-50100 2 WASHER TOOTHED 0.0022
070 31301-34303 1 ASSY LIGHT COMBI.RH 0.8800
080 31301-34320 1 BODY RH 0.3960
090 31301-34340 1 LENS 0.2310
100 31391-34350 1 GASKET 0.0044
110 31391-34360 1 BULB 0.0396 23W
120 31301-34370 1 BULB 0.0440 23W/8W
130 31391-34380 2 SCREW 0.0154
130 T1150-34380 2 SCREW 0.0132
140 31301-34313 1 ASSY LIGHT COMBI.LH 0.7040
150 31301-34330 1 BODY LH 0.4620
160 31301-34340 1 LENS 0.2310
170 31391-34350 1 GASKET 0.0044
180 31391-34360 1 BULB 0.0396 23W
190 31301-34370 1 BULB 0.0440 23W/8W
200 31391-34380 2 SCREW 0.0154
200 T1150-34380 2 SCREW 0.0132
 F2803-ELA FOR M4900
51 ELECTRICAL SYSTEM 51
B51000 ELECTRICAL WIRING

ITEM PART QTY PART NAME WGT. REMARK S/N

010 3A211-77212 1 WIRE HARNESS 3.0470 <=13409
010 3A211-77214 1 WIRE HARNESS 4.2900 =>13410
030 3A211-77350 1 CASE FUSE 0.1166
040 3A211-77370 1 COVER FUSE CASE 0.0198 <=13409
040 3A221-77370 1 COVER FUSE CASE 0.0220 =>13410
050 36730-75550 3 FUSE AUTO 0.0066 10A
060 35820-75560 4 FUSE AUTO 0.0044 15A
070 35080-34530 1 FUSE 0.0110 50A
080 3A011-77224 2 WIRE HARNESS 0.3300 <=12438
080 3A211-77220 2 WIRE HARNESS 0.2200 =>12439
090 3A011-77300 2 WIRE HARNESS EARTH 0.0176
100 03034-50616 2 SCREW WITH WASHER 0.0132
105 01125-60820 1 BOLT 0.0330
110 55311-41260 3 BAND CORD 0.0154
120 53581-64150 4 BAND CORD 0.0044
130 13824-67590 1 CLAMP CORD 0.0044
140 35340-29380 3 CLAMP CORD 0.0220