Automated Hematology Analyzer: MEK-7300K

Automated
Hematology Analyzer
MEK-7300K
If you have any comments or suggestions

on this manual, please contact us at:
www.nihonkohden.com 0634-900905
In order to use this product safely and fully understand all its functions, make sure to read this manual before using the
product.
Keep this manual near the instrument or in the reach of the operator and refer to it whenever the operation is unclear.
The contents of this manual are subject to change without notice.
Copyright Notice
The entire contents of this manual are copyrighted by Nihon Kohden. All rights are reserved. No part of this document
may be reproduced, stored, or transmitted in any form or by any means (electronic, mechanical, photocopied, recorded,
or otherwise) without the prior written permission of Nihon Kohden.
Trademark
The mark printed on the SD card that is used in this instrument is a trademark. The company name and model name are
trademarks and registered trademarks of each company.
After signing this non-disclosure agreement or equivalent, you can use the technical reference manual.
Non-Disclosure Agreement (Sample)
THIS AGREEMENT between (COMPANY) and Nihon Kohden Corporation (NK),

effective from the date stated below by COMPANY, shall govern the conditions of disclosure of the Technical Reference
Manual and other confidential technical information given to COMPANY by NK relating to Nihon Kohden hematology
analyzer (collectively “Confidential Information”).
COMPANY hereby agrees not to disclose Confidential Information to any other party or copy the Confidential Information
without the express written consent of NK. Upon request of NK, COMPANY shall immediately return the Technical
Reference Manual, including all copies, to NK.
THIS AGREEMENT shall not apply to the following information.

(a) Publicly known before or after disclosure by NK through no fault of COMPANY.
(b) In the possession of COMPANY before disclosure by NK.
(c) Acquired by COMPANY from a third party having an independent right to disclose the information.
If COMPANY causes damage to NK against THIS AGREEMENT, COMPANY shall make compensation for the damage.
When any discrepancy occurs in the interpretation of THIS AGREEMENT or when any discrepancy occurs between
COMPANY and NK in regard to matters not stipulated in THIS AGREEMENT, COMPANY and NK shall discuss the
discrepancy amicably in order to reach a solution in good faith.
Two copies of THIS AGREEMENT shall be made and signed by COMPANY and NK. COMPANY and NK shall each
have one copy of THIS AGREEMENT.
COMPANY NK
Date: Date:
Company: Nihon Kohden Corporation
Address: 1-31-4, Nishiochiai, Shinjuku-ku, Tokyo

Signature: Signature:
Signee’s name in block letters:
Technical Reference Manual MEK-7300K N.1

Contents 1
Section 1 Replaceable Parts List........................................................... 1.1

Composition...................................................................................................................... 1.3
Units and Boards.............................................................................................................. 1.6
Units....................................................................................................................... 1.6
Boards.................................................................................................................... 1.8
Chassis........................................................................................................................... 1.10
MC-730V CBC Measuring Unit....................................................................................... 1.12
MJ-730V Flow Cytometry Piping Unit............................................................................. 1.14
YZ-002B1 (VALVE PLATE 3P45IN ASSY): 602.............................................................. 1.16
YZ-002B2 (VALVE PLATE 2POUT ASSY): 603.............................................................. 1.17
YZ-002B3 (VALVE PLATE 4PIN ASSY): 604.................................................................. 1.18
YZ-002B4 (VALVE PLATE 2P45IN ASSY): 605.............................................................. 1.19
Flow Cell Adjusting Fixture............................................................................................. 1.22
MP-640V Pump Unit....................................................................................................... 1.23
MP-730V Mixed Pump Unit............................................................................................. 1.24
MP-731V Triple Pump Unit.............................................................................................. 1.25
MS-730V Sampler Unit................................................................................................... 1.26
MS-731V Cap Pierce Unit............................................................................................... 1.28
JQ-731V/JQ-732V Valve Unit.......................................................................................... 1.29
JQ-730V Inlet/Outlet Unit................................................................................................ 1.30
YZ-003B1 (VALVE PLATE 3PIN ASSY): 712.................................................................. 1.32
Power Supply Unit.......................................................................................................... 1.33
PV-730VK Front Panel Unit............................................................................................. 1.34
WA-730VK Printer........................................................................................................... 1.36
Section 2 Cable Wiring and Tube List.................................................... 2.1

Cable Wiring..................................................................................................................... 2.2
SOCKET HOUSING......................................................................................................... 2.9
Tube List......................................................................................................................... 2.10
Hydraulic System Diagram............................................................................................. 2.11
Block Diagram................................................................................................................. 2.12
Technical Reference Manual MEK-7300K C.1

Section 1 Replaceable Parts List 1
Composition.......................................................................................................................................................... 1.3
Units and Boards.................................................................................................................................................. 1.6
Units........................................................................................................................................................... 1.6
Boards........................................................................................................................................................ 1.8
Chassis............................................................................................................................................................... 1.10
MC-730V CBC Measuring Unit.......................................................................................................................... 1.12
MJ-730V Flow Cytometry Piping Unit................................................................................................................. 1.14
YZ-002B1 (VALVE PLATE 3P45IN ASSY): 602.................................................................................................. 1.16
YZ-002B2 (VALVE PLATE 2POUT ASSY): 603.................................................................................................. 1.17
YZ-002B3 (VALVE PLATE 4PIN ASSY): 604...................................................................................................... 1.18
YZ-002B4 (VALVE PLATE 2P45IN ASSY): 605.................................................................................................. 1.19
Flow Cell Adjusting Fixture................................................................................................................................. 1.22
MP-640V Pump Unit........................................................................................................................................... 1.23
MP-730V Mixed Pump Unit................................................................................................................................ 1.24
MP-731V Triple Pump Unit................................................................................................................................. 1.25
MS-730V Sampler Unit....................................................................................................................................... 1.26
MS-731V Cap Pierce Unit.................................................................................................................................. 1.28
JQ-731V/JQ-732V Valve Unit............................................................................................................................. 1.29
JQ-730V Inlet/Outlet Unit.................................................................................................................................... 1.30
YZ-003B1 (VALVE PLATE 3PIN ASSY): 712...................................................................................................... 1.32
Power Supply Unit.............................................................................................................................................. 1.33
PV-730VK Front Panel Unit................................................................................................................................ 1.34
WA-730VK Printer.............................................................................................................................................. 1.36
Technical Reference Manual MEK-7300K 1.1

1. REPLACEABLE PARTS LIST
When ordering parts or accessories from your nearest Nihon Kohden Corporation
representative, please quote the NK code number and part name which are listed
in this service manual, and the name or model of the unit in which the required
part is located. This will help us to promptly attend to your needs.
Always use Nihon Kohden parts and accessories to assure maximum
performance from your instrument.
Rank
A Requires replacement within about 1 to 3 months.
B Requires replacement within about 6 to 12 months.
C Requires replacement when this component has deterioration or damage.
D Requires replacement which must be done by service personnel trained in Nihon Kohden or by representative.
1.2 Technical Reference Manual MEK-7300K

1
Composition
MEK-7300K UT-7241 MAIN BD
UT-7242 POWER BD
UT-7243 DRIVER BD
UT-7244 ANALOG BD
UT-7238 VALVE CONNECTION BD1
MC-730V CBC Measuring Unit
UT-7201 HGB AMP BD
UT-7202 HGB LED BD
UT-7249 MEASURING BD (RBC)
UT-7249 MEASURING BD (WBC)
UT-7250 CONNECTION BD
XP-602V 2-way Valve (× 2)
MJ-730V Flow Cytometry Piping Unit
XP-513V 3-way Valve

MO-820V2 LASER OPTICAL UNIT
MF-820V2 FLOWCELL UNIT
UT-7172 MO PREAMP BD
UT-7173 MO FS PREAMP BD
UT-7174 MO FL PREAMP BD
UT-7175 MO SD PREAMP BD
UT-7176 MO LD DRIVER BD
MP-640V Pump Unit
MP-640V Pump Unit
MP-730V Mixed Pump Unit
UT-7200 MIXED PUMP BD
XP-513V 3-way Valve
MP-731V Triple Pump Unit
MS-730V Sampler Unit
UT-7234 SAMPLER JUNCTION BD
UT-7235 SAMPLER SENSOR BD
MS-731V Cap Pierce Unit
JQ-730V Inlet/Outlet Unit
UT-7236 LIQUID SENSOR BD

1
JQ-731V Valve Unit
XP-612V 2-way Valve
JQ-732V Valve Unit
PV-730VK Front Panel Unit
UT-7246 LCD BD
UT-7247 KEY BD
UT-7248 PRINT KEY BD
WA-730VK
UT-7205 PRINTER DRIVER BD

Units and Boards
Units
Rank Index Model Qty Description

C 100 MC-730V 1 CBC measuring unit
C 200 MS-730V 1 Sampler unit
C 300 MS-731V 1 Cap pierce unit
C 400 MP-730V 1 Mixed pump unit
C 500 MP-731V 1 Triple pump unit
D 600 MJ-730V 1 Flow cytometry piping unit
C 700 JQ-730V 1 Inlet/Outlet unit
C 800 PV-730VK 1 Front panel unit
C 900 WA-730VK 1 Internal printer
C 1000 MO-820V2 1 Laser optical unit
C 1200 — 1 Power supply unit
C 1300 MP-640V 2 Rotary pump unit
C 1400 JQ-731V 1 Valve unit
C 1500 JQ-732V 1 Cap pierce valve unit
1000
800
700
200
500
100
400
900
1400 600
300
1500
1300
1300

1200
400
CHASSIS
38
37
500
700
600
1100
1300
1000
1300
1500
200
300
1400
900
100
800

Boards

C A UT-7238 1 VALVE CONNECTION BD1
C G UT-7239 1 VALVE CONNECTION BD2
C B UT-7240 1 VALVE CONNECTION BD3
C C UT-7241 1 MAIN BD†2
C D UT-7242 1 POWER BD
C E UT-7243 1 DRIVER BD
C F UT-7244 1 ANALOG BD
C L UT-7249 2 MEASURING BD†1
C M UT-7250 1 CONNECTION BD†1
C N UT-7201 1 HGB AMP BD†1
C O UT-7202 1 HGB LED BD†1
C P UT-7234 1 SAMPLER JUNCTION BD
C Q UT-7235 1 SAMPLER SENSOR BD
C S UT-7200 1 MIXED PUMP BD
C R UT-7236 1 LIQUID SENSOR BD
C H UT-7246 1 LCD BD
C I UT-7247 1 KEY BD
C J UT-7248 1 PRINTER KEY BD
C K UT-7205 1 PRINTER DRIVER BD
†1
Refer to “MC-730V CBC Measuring Unit”.
†2
UT-7241 battery: 619403 *
*Use the part with the latest suffix except in special circumstances.
F
P
R
G
H
A
†2
∗
Battery: 619403
B
UT-7241

R
D
A
E
B
F

Chassis
Rank Index Code No. Qty Description

C 1 127925 * 1 Bolt Spacing UN18-2102-0006 (L10)
C 2 6114-921051 * 1 PLATE
C 3 6114-921042 * 1 MO BLIND PLATE (73)
C 4 6111-903754 * 1 Cover (73)
C 5 6112-907739 * 1 Side cover (73)
C 6 6121-900337 * 1 Rear cover (73)
C 7 6124-903907 * 1 Key Switch Label (M2)
C 8 6114-920783 * 1 LOCK PLATE (73)
C 9 344254 * 3 Grommet G105
C 10 128514 * 2 UN18-2102-0036 L=50
C 11 6113-032014 * 1 Single manifold
C 12 533941 * 4 Rubber feet TK-38
C 13 9000-005888 * 2 Slide rail BT200-L100
C 14 9000-005995 * 10 Grommet NG-79-P
C 15 6113-916032 * 1 Holder (JQ-730V)
D 16 6141-900451 * 1 Chassis ASSY (73)
C 17 6114-919731 * 1 Sensor holder (73)
C 18 6114-919749 * 1 Tube cover (73)
C 19 6113-915443 * 1 SW Holder
C 20 6113-915381 * 1 DILUTER SW (73)
C 21 6114-920872 * 1 SHEET (VALVE CONNECTION1)
C 22 6114-920863 * 2 SHEET (PUMP)
C 23 297821 * 1 Grommet rubber bush 15C
C 24 553144 * 4 O-ring P-3 (fluorocarbon rubber)
C 25 6114-906406 * 4 Tube fitting nut
C 26 6114-906398 * 4 Tube stopper
C 27 6113-032005 * 1 Manifold (3P)1
C 28 128185 * 1 Bolt Spacing UN18-2102-0015 L19
C 29 533816 * 24 Grommet G-26
C 30 6113-915452 * 1 Slide plate (73)
C 31 6114-920907 * 4 GASKET STGZ 10-10 L100
C 32 6114-920899 * 5 GASKET STGZ 5-5 L100
C 33 6114-923646 * 1 GASKET STGH 10-10 L240
C 34 6114-923655 * 1 GASKET STGZ 10-10 L400
C 35 9000-012194 * 1 109P0612H757
C 36 6114-924654 * 1 Fan guard (73)
C 37 486047 * 1 Micro SW V-10-3A5
C 38 676769 * 2 Photo-interrupter KI-1234-AALF
* Use the part with the latest suffix except in special circumstances.

2
4
34
1
32
14
29 18
Technical Reference Manual MEK-7300K

30
11 6
16 21
15
8 13
10
29
5
28 36
31
13
35
27
9 38
24
23 26
12 25
17
31
20 19 37
1.11
1
MC-730V CBC Measuring Unit
Rank Index Model/Code No. Qty Description

C 101 YZ-002B9 1 MC TRAY ASSY
C 102 6114-919099 * 2 MC Dripping Cover (73)
D 103 6114-919152 * 3 Bath Block Fitting S-IN
C 104 YZ-001B8 2 Bath ASSY (7300)
C 105 YZ-001B0 2 Manometer ASSY
C 106 YZ-0402 1 HGB case ASSY
C 107 YZ-0287 2 Vacuum chamber assy
C 108 6114-922683 * 2 Shield gasket STGZ10-10 (L=135)
C 109 6114-922692 * 3 Shield gasket STGZ10-10 (L=20)
C 110 6113-914925 * 1 MC Case (73)
C 111 YZ-0283 2 Sub bath assy (8222)
D 112 553242 * 2 Stepping motor SPG20-41868G036-309
C 113 6114-903989 * 1 Screw
C 114 2114-065847 * 1 Rubber packing 1
C 115 2114-080812 * 1 Bath cap
C 116 6114-067438 * 3 Filter joint (black)
C 117 676769 * 2 Photo interruptor KI1235-AALF
C 118 2114-050997 * 13 Joint spring
C 119 2114-051033 * 10 Joint collar.2
C 120 6114-067456 * 7 Tube joint.1
C 121 6114-067465 * 3 Tube joint.2
C 122 553144 * 13 O-ring (fluorocarbon rubber)
C 123 315375 * 1 O-ring (red silicone rubber)
C 124† 553233 * 2 O-ring (red silicone rubber)
C 125† 556827 * 2 O-ring (fluorocarbon rubber)
C 126 344254 * 2 Grommet G106
B 127 2114-082062 * 2 Filter packing S
C 128 2114-080171 * 1 Bath fitting collar
C 129 6113-043305 * 1 Air trap
C 130† 9000-023093 * 2 Aperture (80)
C 131 6114-906398 * 13 Tube stopper
A 133 *
6144-001899 (T802) 2 Filter ASSY (PP)
C 134 2114-073972 * 2 Filter collar•A
D 135 YZ-0412 7 2-way valve XP-612V
C 137 6113-914907 * 1 HGB Shield Case
D 138 6113-914916 * 1 Sub bath holder
C 139 6112-907632 * 1 MC front chassis
D 140 6114-919205 * 4 MC bush
C 141 6114-919214 * 4 MC collar
C 142 126481 * 4 M3 spacer TM-147 NO.1
†
YZ-0345 consists of 124, 125 and 130.

101 M
122
132
c
112
131
107
139
138 142 107
a
b
112 c 136
117
111 108

103
111
136
110
120 109
140
118
141
119 135
126
123
135
129 142
127
133 135
102
104 114 115 b
134
a
125 O N
116 124
135
121
130
118
128 105
113 106 105 119
137 L L
1.13
1
MJ-730V Flow Cytometry Piping Unit
Rank No. Model/Code No. Qty Description

C 601 YS-025B8 1 Waste chamber ASSY
C 602 YZ-002B1 1 Valve plate 3P45INASSY
C 603 YZ-002B2 1 Valve plate 2POUTASSY
C 604 YZ-002B3 1 Valve plate 4PINASSY1
C 605 YZ-002B4 1 Valve plate 2P45INASSY
C 606 YZ-002B5 1 Valve plate 4POUTASSY2
C 607 YZ-002B6 2 Valve plate 3POUTASSY
C 608 YZ-0416 2 Pinch valve
C 609 YZ-001B2 1 Heater ASSY (7300)
C 610 YZ-001B9 1 Mixing chamber ASSY
C 611 YZ-002B7 1 Pressure chamber ASSY
C 612 YZ-0288 1 Air chamber ASSY
C 613 344254 * 1 Grommet G105
C 614 321332 * 1 Grommet NG-79L
C 615 6113-027074 * 1 Valve holder
C 616 6114-122994 * 3 Tube joint ID1F
C 617 6114-123003 * 2 Tube joint ID1
C 618 6114-123048 * 1 Tube joint ID05
C 620 6114-906398 * 30 Tube stopper

616 602 618
611 615
603
622
617
608
613 619
604
620

612 621
609
614
610 605
601 a
617
608
606
607
607
616
1.15
1
YZ-002B1 (VALVE PLATE 3P45IN ASSY): 602

D 1 6113-915176 * 1 Valve plate 3P45
D 2 6114-919794 * 1 Valve block O-ring S-IN
D 3 6113-915407 * 1 Valve block fitting T-IN
D 4 6113-915514 * 1 Valve block O-ring T-IN
D 5 6114-923762 * 2 Port O ring Ø 1.6 hardness 60
D — YZ-0412† 3 2-way valve XP-612V
†
YZ-0412 consists of XP-612V and cables.
4 3
1 2 5
5
YZ-0412

1
YZ-002B2 (VALVE PLATE 2POUT ASSY): 603

D 1 6113-916023 * 1 Valve plate 2P
D 2 6114-919847 * 1 Valve block O-ring S-OUT
D 3 6114-919811 * 1 Valve block fitting T-OUT
D 4 6114-136462 * 1 Port O-ring (silicone SN6021)
†
3
4
YZ-0412

YZ-002B3 (VALVE PLATE 4PIN ASSY): 604

D 1 6113-915167 * 1 Valve plate 4P
D 6 297919 * 1 Grommet rubber bush G99
†
3
4
4 5
5
YZ-0412
6 2 5

1
YZ-002B4 (VALVE PLATE 2P45IN ASSY): 605

D 1 6113-916888 * 1 Valve plate 2P45
D 4 6114-923762 * 1 Port O ring Ø 1.6 hardness 60
†
1 2 3
4
YZ-0412


D 1 6113-915167 * 1 Valve plate 4P
D 4 6114-919838 * 2 Valve block O-ring T-OUT
†
6
1
3
4
4 5
5
YZ-0412
2
5

1

D 1 6113-915755 * 1 Valve plate 3P
D 4 6114-919838 * 1 Valve block O-ring T-OUT
†
3
4
5
YZ-0412 5
2
6

Flow Cell Adjusting Fixture

C 1101 553215 * 1 O-ring P-15 (Silicon)
C 1102 6114-923058 * 1 Lock screw plate
C 1103 6114-919696 * 1 Scree holder
C 1104 6114-919678 * 1 O-ring holder
C 1105 6114-919651 * 1 Hex adaptor
YZ-003B0
1100
1102
1103
1101
1104
1105
YZ-003B0 (MO unit) does not include a flow cell adjustment part.

1
MP-640V Pump Unit

C 1301 YS-003B4 1 Rotor assy
A 1302 YS-001B1 (T462) 1 Pump tube (N) assy
1302
1301

MP-730V Mixed Pump Unit

C 401 YZ-001B1 1 Sheath cylinder assy (7300)
C 402 YZ-001B4 1 Diluter cylinder assy (7300)
C 403 6114-920997 * 1 DRIP PROOF SHEET (MP-730V)
D 404 686954 * 2 Stepping motor
D 405 6113-027074 * 1 Valve holder
C 406 6114-906398 * 3 Tube stopper
D 407 487296 * 2 Universal coupling
C 411 676769 * 2 Photosensor KI1234-AALF
405
404
401
404
407 410
409
406
408
411
407
402
403

1
MP-731V Triple Pump Unit

C 501 YZ-001B5 3 Cylinder assy
C 502 6114-921015 * 1 DRIP PROOF SHEET (MP-731V)
D 503 693171 * 2 PK Coupling PK60M-29 A3B5
C 504 6113-027074 * 2 Valve holder
C 507 6114-906398 * 3 Tube stopper
C 509 YZ-0410 2 3-way valve XP-513V
C 510 676769 * 4 Photosensor KI1234-AALF
C 37† 6114-925154 * 1 TRAY (MP-731V)
C 38† 6114-925163 * 1 Absorber Sheet
37 and 38 are the parts of chassis, not of unit.
†
505
505
503
503 509
504
510
506
507 508
510
510
502 510
38
37
501

MS-730V Sampler Unit

C 201 6114-919339 * 1 Sample tube guide (73)
C 202 6114-926304 * 1 Sample cup (filter) 73
D 203 YK-00016 1 MS-730V tube ASSY
C 204 297821 * 1 Grommet rubber bush 15C
C 205 6114-914451 * 1 Filter joint (82)
C 206 6114-122994 * 1 Tube joint ID1F
C 207 6114-914469 * 1 Screw (82)
C 208 686963 * 2 KH42KM2R082
C 209 6144-900124 * 2 Sample tube ASSY
C 210 6114-902606 * 2 Sampling nozzle fastening screw
C 211 688212 * 2 Shaft coupling
C 212 YZ-0354 1 Rinse unit assy for open mode
C 214 2114-050997 * 1 Joint spring
A 215 *
6144-001899 (T802) 1 Filter ASSY (PP)
C 216 904087 * 1 SML2CD-28X190-BDX10BL-P1.25-S5
C 217 9000-005914 * 2 Flat clamp FCR-45 V0
C 218 2114-073972 * 1 Filter collar

208
208
203
210 211
210
211
209

209
217
P
216
204
202
207
213
215
206
201
212
214
218
205
1.27
1
MS-731V Cap Pierce Unit

D 301 YZ-002B0 1 Cap pierce base ASSY (7300)
C 302 6114-906905 * 1 Filter manifold
C 303 YZ-0342 1 Cap pierce needle assy
C 304 YZ-0365 1 Rinse unit assy for closed mode
A 305 *
6144-001899 (T802) 1 Filter ASSY (PP)
C 307 6114-920061 * 1 Protect seat
C 308 YZ-001B3 1 Open solenoid (7300)
C 309 676769 * 2 Photo-interrupter KI-1234-AALF
D 311 517086 * 1 Shaft coupling
C 312 9000-000893 * 2 Photo-interrupter LG217L-3
C 313 9000-005834 * 1 COMPONENT CLIP V-1005
312
303
312
313
311 302
306
305
304
310
309
309
a
a
301 307
308

1
JQ-731V/JQ-732V Valve Unit

1401
1501

JQ-730V Inlet/Outlet Unit

C 701 6124-041643 * 1 EMERGENCY SW Label
C 702 6113-034476 * 4 Bubble detector (6300)
C 703 6124-905861 * 1 MEK-7300 Port label
D 704 6143-901838 * 1 Chassis ASSY (JQ-730V)
D 705 6113-915318 * 1 JQ-730V Chassis3
C 706 6113-915327 * 1 Port Panel (73)
D 707 6114-919152 * 1 Valve block fitting S-IN
C 708 6114-906398 * 11 Tube stopper
D 711 6114-920578 * 1 JQ Joint
C 712 YZ-003B1 1 Valve plate 3PINASSY
C 713 6114-920587 * 1 JQ Manifold
C 714 6114-919571 * 1 Laser SW blanket
C 715 127907 * 1 Spacer UN18-2102-0008 L12
C 716 127934 * 1 Spacer UN18-2102-0014 L18
C 717 344254 * 1 Grommet G105
C 718 2114-051042 * 1 Joint.5 nut

1
R
702
710
708
709
712
714
707
705
710 716
715
717
713
711
704 706
b
a
701
718
703

YZ-003B1 (VALVE PLATE 3PIN ASSY): 712

D 1 6113-915755 * 1 Valve plate 3P
†
2
4
YZ-0412

1
Power Supply Unit

C 1201 2124-009676 * 1 Function earth nameplate
C 1202 2224-001102 * 1 EARTH nameplate
C 1203 6142-901457 * 1 SC chassis
C 1204 6113-915924 * 1 Plate (SC)
C 1205 6144-005993 * 1 Equipotential terminal
C 1206 936836* 1 LEP240F-24
C 1207 313635* 1 Power entry module FN284-4-06
1203
1207 D
1205
1202
1201
1204
1206

PV-730VK Front Panel Unit

C a 932689 * 1 PHR-7/51021-0700 (W110) Red
C e 938834 * 1 LY10-DC22/DC14/DC8 (W130/270)
C f 932671 * 1 DF19G-20S-1C (W170)
D 801 639088 * 2 Flat hinge TH-TM-112
D 802 6122-901183 * 1 FRONTCASE Printing (73)
D 803 6141-900469 * 1 PV Chassis ASSY
C 805 6113-915488 * 1 Inverter cover
D 806 6113-916941 * 1 LCD Plate
D 807 6113-915461 * 1 Front bracket (73)
C 808 6113-915996 * 1 SHEET (PV-BOTTOM)
C 809 6113-915987 * 1 SHEET (PV-BD)
C 810 6114-920845 * 1 ISOLATION SHEET (INVERTER73)
D 812 6114-911908 * 1 Round key top cover (ivory, large)
D 813 6114-911882 * 1 Oval key top cover (ivory)
D 814 6114-094266 * 1 Round key top cover (orange, small)
D 815 6114-911891 * 4 Round key top cover (ivory, small)
D 816 6112-904475 * 1 Touch panel washer
D 817 297821 * 2 Grommet rubber bush 15C
C 818 693153 * 2 Flat cable tie
D 819 6114-920916 * 2 GASKET STGZ 7-10 L180
D 820 6114-920934 * 1 GASKET STGZ 3-5 L180
D 821 6114-920925 * 2 GASKET STGZ 7-7 L60
D 822 6114-920943 * 2 GASKET STGZ 3-5 L35
D 823 905995 * 1 LTA104D182F
D 824 914218 * 1 Touch panel N010-0554-T347A
D 825 913959 * 1 CXA-0454
C 830 6112-907855 * 1 BLIND PANEL (73)

825
823
805
810
a
806 816
e
820 H
f 818
I

821
824
809
807
817
802
819
812 801
814
815 822
817
813
815
803
830
808
1.35
1
WA-730VK Printer

D 804 6112-907873 * 1 PRINTER DOOR (73)
C 811 6124-906316 * 1 WA-730V Printer label
D 826 6113-901449 * 1 Printer case
D 827 6113-900985 * 1 Printer holder
C 828 483273 * 1 Thermal array printer head
C 829 301488 * 2 Magnet R28E
C K UT-7205 1 PRINTER DRIVER board

Section 2 Cable Wiring and Tube List
2
Cable Wiring......................................................................................................................................................... 2.2

SOCKET HOUSING............................................................................................................................................. 2.9
Tube List............................................................................................................................................................. 2.10
Hydraulic System Diagram................................................................................................................................. 2.11
Block Diagram.................................................................................................................................................... 2.12

2. CABLE WIRING AND TUBE LIST
Cable Wiring
Rank No. Code No. Qty Cable model or description Connection (Cable ends) Connection (Connector)
C a 932724 * 1 PUDP-34V-S (W400) POWER BD-MAIN BD [CN0501] - [CN1401]
C b 932403 * 1 PUDP-32V-S (W200) Red POWER BD-DRIVER BD [CN0503] - [CN0103]
C c 932555 * 1 PUDP-30V-S (W160) Orange POWER BD-ANALOG BD [CN0505] - [CN0001]
C d 938638 * 1 LY10-DC14 (W150) Twist pair MAIN BD-DRIVER BD [CN1501] - [CN0101]
C e 932501 * 1 PUDP-22V-S (W180) MAIN BD-DRIVER BD [CN1502] - [CN0102]
C f 932377 * 1 PUDP-20V-S (W180) MAIN BD-DRIVER BD [CN1503] - [CN0104]
C g 932493 * 1 PUDP-28V-S (W50) MAIN BD-ANALOG BD [CN1301] - [CN0301]
C h 938647 * 1 PUDP-36V-S (W120) MAIN BD-ANALOG BD [CN1302] - [CN0202]
C i 932528 * 1 LY10-DC28 (W70) Green-White MAIN BD-ANALOG BD [CN1401] - [CN0201]
C j 932537 * 1 PUDP-32V-S (W340) Purple MAIN BD-CONNECTION BD [CN1201] - [CN106]
C k 938656 * 1 PUDP-08V-S (W550) White ANALOG BD-MC (CONNECTION BD) [CN0401] - [CN102]
C l 938665 * 1 VHR-10N (W640) Red ANALOG BD-MC (CONNECTION BD) [CN0402] - [CN105]
C m 938674 * 1 LY10-DC14 (W340) Blue MAIN BD-LIQUID SENSOR BD [CN1701] - [CN0102]
C n 938683 * 1 LY10-DC8 (W460) Twist pair MAIN BD-LCD BD [CN1601] - [CN0104]
C o 9000- 1 LY10-DC10BR (W550/600)-Tube MAIN BD-LCD BD [CN1602] - [CN0102]
009803 *
C p 938709 * 1 LY10-DC20 (W420) Brown-White MAIN BD-LCD BD [CN1603] - [CN0103]
C q 932448 * 1 LY10-DC16 (W440) Yellow-White MAIN BD-SAMPLER JUNCTION BD [CN1605] - [CN0101]
C r 932733 * 1 LY10-DC22 (W310) Blue-White DRIVER BD-VALVE CONNECTION BD1 [CN2502] - [CN0111]
C s 938718 * 1 LY10-DC20 (W390) Purple-White DRIVER BD-VALVE CONNECTION BD1 [CN2101] - [CN0104]
C t 938727 * 1 LY10-DC32 (W440) Gray-White DRIVER BD-VALVE CONNECTION BD1 [CN2502] - [CN0105]
C u 938736 * 1 LY10-DC44 (W240) Orange-White DRIVER BD-VALVE CONNECTION BD2 [CN2504] - [CN0201]
C v 932457 * 1 LY10-DC12 (W230) Brown-White DRIVER BD-VALVE CONNECTION BD3 [CN2503] - [CN0301]
C w 932368 * 1 PUDP-16V-S (W700) POWER BD-LCD BD [CN0506] - [CN0101]
C x 938843 * 1 LY10-DC22 (W320) Red-White DRIVER BD-MC (CONNECTION BD) [CN0902] - [CN100]
C y 910641 * 1 171822-2/PS-187 (W190) Blue VALVE CONNECTION BD1-Switch [CN0107] - Switch
C z 938897 * 1 PUDP-14V-S (W220) Green POWER BD-LIQUID SENSOR BD [CN0504] - [CN0101]
C aa 938745 * 1 LY10-DC18 (W200) Green-White DRIVER BD-MIXED PUMP BD [CN1102] - [CN011]
C ab 938807 * 1 LY10-DC18/51090-0900 (W470/300) DRIVER BD-Sub Bath junction connector [CN0901] - Junction connector
C ac 932626 * 1 PUDP-12V-S/PHR-11 (W330) SP DRIVER BD-Sampler motor [CN2301] - Motor×2
C 1a 938763 * 1 LY10-DC38/24/DF11-16DS (W140) CONNECTION BD-MEASURING BD [CN103] - [CN100]
Red (RBC) [CN104]
C 1b 938772* 1 LY10-DC38/24/DF11-16DS (W140) CONNECTION BD-MEASURING BD [CN107] - [CN100]
White (WBC) [CN108]
C 1c 938781* 1 HGB BD Cable (MEK-7300) (W160) CONNECTION BD-HGB AMP BD [CN400] - [CN051]
-HGB LED BD - [CN302]
C 1d 938941* 2 XHP-3/V0.5-2/-4 (W45) Red-Black MEASURING BD-MC Electrode [CN300] - Electrode
C 1e 9000- 2 Sub bath cable (MEK-7300) (W100) Sub bath junction connector Sub bath motor Junction-Motor
003266*
C 4a 938914* 1 PUDP-16V/PHR-11/ZHR-3/Green DRIVER BD-Sheath pump motor [CN1501] - Motor
- Sensor×2
C 4b 932582* 1 PUDP-10V-S/PHR-11(W220)SP DRIVER BD-MD Motor [CN1101] - Motor
C 5a 938905* 1 PUDP-14V/PHR-11/ZHR-3/Purple DRIVER BD-LYSE Pump motor [CN1001] - Motor
- Sensor×2
C 5b 932644* 1 PUDP-18V/PHR-11/ZHR-3 Blue DRIVER BD-Sample pump motor [CN1301] - Motor
- Sensor×2
C 3a 938888* 1 Cap pierce cable (MEK-7300) VALVE CONNECTION BD1-Cap pierce [CN0101] - Motor
- Sensor×4
- Solenoid
C 8a 932689* 1 PHR-7/51021-0700 (W110) Red LCD BD-Inverter [CN0203] - Inverter
C 8b 938834* 1 LY10-DC22/DC14/DC8 (W130/270) LCD BD-KEY BD [CN0201] - [CN0301]
LCD BD-PRINT KEY BD - [CN0401]
C 8c 932671 * 1 DF19G-20S-1C (W170)-Tube LCD BD-LCD [CN0105] - LCD
C 8d 938754 * 1 LY10-DC16 (W390) Brown MAIN BD-PRINTER BD [CN1604] - [CN011]
C 12a 938923 * 1 VHR-5/SFO-61T-250A (W70/80/150) AC Inlet-Switching Power supply AC Inlet-Switching Power
supply [CN1]
C 12b 938932 * 1 VHR-8N (W120) Black-Red POWER BD-Switching Power supply [CN0101] - Switching Power
supply [CN2]
C 12c 9000- 1 V1.25-4/SFO-61T-250A (W70) AC Inlet-Chassis AC Inlet-Chassis
003275 *
C 7a 9000- 1 ELR-02V/171822-3 (W610) FAN junction-POWER BD FAN junction - [CN0502]
012247 *
y
5b
5a
4b
aa
4a
r
s
u
r
t
s
t
ac
xab
v
b
d
e
f
c
l
y
ab
v
ab
i
8d
g
m
o
f
e
h
j
n
k
q
p
d
g
i
h

ＮＯ．ａ UT-7242 UT-7241

（POWER BD）（MAIN BD）
【CN0501】 Code no.： 932724 【CN1401】

34 pin 34 pin
Name： PUDP-34V-S (W400)
Color： brown
ＮＯ．ｂ UT-7242 UT-7243

（POWER BD）（DRIVER BD）
【CN0503】 Code no.： 932403 【CN0103】

32 pin 32 pin
Name： PUDP-32V-S (W200) red
Color： red
ＮＯ．ｃ UT-7242 UT-7244

（POWER BD）（ANALOG BD）
【CN0505】 Code no.： 932555 【CN0001】

30 pin 30 pin
Name： PUDP-30V-S (W160) orange
Color： orange
ＮＯ．ｄ UT-7241 UT-7243

（MAIN BD）（DRIVER BD）
【CN1501】 Code no.： 938638 【CN0101】

14 pin 14 pin
Name： LY10-DC14 （Ｗ150） twist pair
Color： multicolor
ＮＯ．ｅ UT-7241 UT-7243

【CN1502】 Code no.： 932501 【CN0102】

22 pin 22 pin
Color： black
ＮＯ．ｆ UT-7241 UT-7243

【CN1503】 Code no.： 932377 【CN0104】

20 pin 20 pin
Color： white
ＮＯ．ｇ UT-7241 UT-7244

（MAIN BD）（ANALOG BD）
【CN1301】 Code no.： 932493 【CN0301】

28 pin 28 pin
Color： yellow
ＮＯ．ｈ UT-7241 UT-7244

【CN1302】 Code no.： 938647 【CN0202】

36 pin 36 pin
Color： green
ＮＯ．ｉ UT-7241 UT-7244

【CN1402】 Code no.： 932528 【CN0201】

28 pin 28 pin
Name： LY10-DC28 (W70) green and white
Color： green and white
ＮＯ．ｊ UT-7241 UT-7250

（MAIN BD）（CONNECTION
BD）
【CN1201】 Code no.： 932537 【CN106】

32 pin 32 pin
Name： PUDP-32V-S (W340) purple
Color： purple

ＮＯ．ｋ UT-7244 UT-7250

（ANALOG BD）（CONNECTION
BD）
2
【CN0401】 Code no.： 938656 【CN102】
8 pin 8 pin
Name： PUDP-08V-S (W550) white
Color： white
ＮＯ．ｌ UT-7244 UT-7250

（ANALOG BD）（CONNECTION
BD）
【CN0402】 Code no.： 938665 【CN105】

10 pin 10 pin
Name： VHR-10N (W640) red
Color： red
ＮＯ．ｍ UT-7241 UT-7236

（MAIN BD）（LIQUID
SENSOR BD）
【CN1701】 Code no.： 938674 【CN0102】

14 pin 14 pin
Name： LY10-DC14 (W340) blue
Color： blue
ＮＯ．ｎ UT-7241 UT-7246

（MAIN BD）（LCD BD）
【CN1601】 Code no.： 938683 【CN0104】

8 pin 8 pin
Name： LY10-DC8 (W460) twist pair
Color： black, brown, red, orange and white
ＮＯ．ｏ UT-7241 UT-7246

【CN1602】 Code no.： 9000-009803 【CN0102】

10 pin 10 pin
Name： LY10-DC10BR (W550/600) with tube
Color： black and white
ＮＯ．ｐ UT-7241 UT-7246

【CN1603】 Code no.： 938709 【CN0103】

20 pin 20 pin
Name： LY10-DC20 (W420) brown and white
Color： brown and white
ＮＯ．ｑ UT-7241 UT-7234

（MAIN BD）（SAMPLER
JUNCTION BD）
【CN1605】 Code no.： 932448 【CN0101】

16 pin 16 pin
Name： LY10-DC16 (W440) yellow and white
Color： yellow and white
ＮＯ．ｒ UT-7243 UT-7238

（DRIVER BD）（VALVE
CONNECTION
BD1）
【CN2505】 Code no.： 932733 【CN0111】

22 pin 22 pin
Name： LY10-DC22 (W310) blue and white
Color： blue and white
ＮＯ．ｓ UT-7243 UT-7238

CONNECTION
BD1）
【CN2101】 Code no.： 938718 【CN0104】

20 pin 20 pin
Name： LY10-DC20 (W390) purple and white
Color： purple and white
ＮＯ．ｔ UT-7243 UT-7238

CONNECTION
BD1）
【CN2502】 Code no.： 938727 【CN0105】

32 pin 32 pin
Name： LY10-DC32 (W440) gray and white
Color： gray and white

ＮＯ．ｕ UT-7243 UT-7239

CONNECTION
BD2）
【CN2504】 Code no.： 938736 【CN0201】

44 pin 44 pin
Name： LY10-DC44 (W240) orange and white
Color： orange and white
ＮＯ．ｖ UT-7243 UT-7240

CONNECTION
BD3）
【CN2503】 Code no.： 932457 【CN0301】

12 pin 12 pin
Name： LY10-DC12 (W230) brown and white
Color： brown and white
ＮＯ．ｗ UT-7242 UT-7246

（POWER BD）（LCD BD）
【CN0506】 Code no.： 932368 【CN0101】

16 pin 16 pin
Color： yellow
ＮＯ．ｘ UT-7243 UT-7250

（DRIVER BD）（CONNECTION
BD）
【CN0902】 Code no.： 938843 【CN100】

22 pin 22 pin
Name： LY10-DC22 (W320) red and white
Color： red and white
ＮＯ．ｙ UT-7238
（VALVE
CONNECTION
BD1）
Measurement
【CN0107】 Code no.： 910641 switch
2 pin
Name： XHP-2/PS-187 (W190) blue
Color： blue
ＮＯ．ｚ UT-7242 UT-7236

（POWER BD）（LIQUID
SENSOR BD）
【CN0504】 Code no.： 938897 【CN0101】

14 pin 14 pin
Name： PUDP-14V-S (W220) green
Color： green
ＮＯ．ａａ UT-7243 UT-7200

（DRIVER BD）（MIXED PUMP
BD）
【CN1102】 Code no.： 938745 【CN011】

18 pin 18 pin
Name： LY10-DC18 (W200) green and white
Color： green and white
ＮＯ．ａｂ UT-7243
（DRIVER BD） Sub bath
Connection
Connector
9 pin
ＷＢＣ
【CN0901】
18 pin Code no.： 938807 Sub bath
Connection
Name： LY10-DC18/51090-0900 (W470/300) Connector
Color： red and white 9 pin
ＲＢＣ
ＮＯ．ａｃ UT-7243
（DRIVER BD）
Sampler motor
【CN2301】 Code no.： 932626
12 pin Name： PUDP-12V-S/PHR-11(W330) Sampler motor
Color： blue and green
ＮＯ． 1ａ UT-7250 UT-7249

（CONNECTION （MEASURING
BD） BD）
【CN103】
24 pin Code no.： 938763 【CN100】
38 pin
【CN104】 Name： LY10-DC38/24/DF11-16DS (W140) red
16 pin Color： red

ＮＯ． 1ｂ UT-7250 UT-7249

（CONNECTION （MEASURING
BD） BD）
【CN107】 2
24 pin Code no.： 938772 【CN100】
38 pin
【CN108】 Name： LY10-DC38/24/DF11-16DS (W140) white
16 pin Color： white
ＮＯ． 1ｃ UT-7250 UT-7201

（CONNECTION HGB AMP BD
BD）
【CN051】
4 pin
【CN400】 Code no.： 938781 UT-7202
HGB LED BD
12 pin
Name： HGB BD cable (MEK-7300) (W160)
Color： black 【CN302】
5 pin
ＮＯ． 1ｄ UT-7249
（MEASURING
BD）
【CN300】 Code no.： 938941

3 pin
Name： XHP-3/V0.5-2/-4 (W45) red and black MC electrode
Color： red, white and black
ＮＯ． 1ｅ
Sub bath motor

Sub bath 6 pin
connection Code no.： 9000-003266
connector Name： Sub bath cable (MEK-7300) (W100) Sensor
Color： black 3 pin
ＮＯ． 4ａ UT-7243
（DRIVER BD）
Motor of sheath
11 pin
【CN1501】 Code no.： 938914
16 pin
Name： PUDP-16V/PHR-11/ZHR-3/green
Color： green, black and brown Sensor 3 pin
Sensor 3 pin
ＮＯ． 4ｂ UT-7243
（DRIVER BD）
MD motor
11 pin
【CN1101】 Code no.： 932582
10 pin
Name： PUDP-10V-S/PHR-11 (W280)
Color： yellow
ＮＯ． 5ａ UT-7243
（DRIVER BD）
LYSE motor
11 pin
【CN1001】 Code no.： 938905
14 pin
Name： PUDP-14V/PHR-11/ZHR-3/purple
Color： purple, black and brown Sensor 3 pin
Sensor 3 pin
ＮＯ． 5ｂ UT-7243
（DRIVER BD）
Sample pump motor

11 pin
【CN1301】 Code no.： 932644
14 pin
Name： PUDP-18V/PHR-11/ZHR-3 blue
Color： blue, black and brown Sensor 3 pin
Sensor 3 pin
ＮＯ． 3ａ UT-7238
（VALVE
CONNECTION CAP pierce unit
BD1） motor
11 pin
【CN0101】
Code no.： 938888 Sensor 　3 pin
20 pin Name： Cap pierce cable (MEK-7300) Sensor 　3 pin
Color： white, black, brown, red and orange Sensor 　3 pin
Sensor 　3 pin
Solenoid 2 pin
ＮＯ． 8ａ UT-7246
（LCD BD）
【CN0203】 Code no.： 932689 Inverter

7 pin
Name： PHR-7/51021-0700 (W110) red
Color： red

ＮＯ． 8ｂ UT-7246
（LCD BD） UT-7247
（KEY BD）
【CN0301】
14 pin
【CN0201】 Code no.： 938834 UT-7248
（PRINTER
22 pin
Name： LY10-DC22/DC14/DC8 (W130/270) KEY BD）
Color： white 【CN0401】
8 pin
ＮＯ． 8ｃ UT-7246
（LCD BD）
LCD
20 pin
【CN0105】 Code no.： 932671
20 pin
Name： DF19G-20S-1C (W170) with tube
Color： white
ＮＯ． 8ｄ UT-7241 UT-7205

（MAIN BD）（PRINTER
DRIVER BD）
【CN1604】 Code no.： 938754 【CN011】

16 pin 16 pin
Name： LY10-DC16 (W390) brown
Color： brown
ＮＯ． 12ａ
Code no.： 938923

Name： VHR-5/SFO-61T-250A (W70/80/150) SW power source
AC inlet Color： blue, brown and green 【CN1】
5 pin
ＮＯ． 12ｂ UT-7242

（POWER BD）
SW power source
【CN0101】 Code no.： 938932
8 pin 【CN2】
Name： VHR-8N (W120) black and red 8 pin
Color： red and black
ＮＯ． 12ｃ
AC inlet Chassis
Code no.： 9000-003275
Name： V1.25-4/SFO-61T-250A (W70)
Color： green and yellow
ＮＯ． 7ａ UT-7242
（POWER BD）
Code no.： 9000-012247

FAN connection Name： ELR-02V/XHP-3 (W610) 【CN0502】
connector Color： black and red 3 pin

SOCKET HOUSING
2
Rank NK Code No. Pin Description Remarks

D 670258 * 4 LY10-DC4BR JQ-732V
D 670267 * 6 LY10-DC6BR MC-730V
D 670276 * 8 LY10-DC8BR JQ-730V/JQ-731V
D 670285 * 10 LY10-DC10BR MC-730V
D 670347 * 22 LY10-DC22BR MJ-730V
D 670356 * 24 LY10-DC24BR MJ-730V
LY-DC4BR LY-DC6BR LY-DC8BR LY-DC10BR
LY-DC22BR LY-DC24BR

Tube List
Units Tube Code No. Tube Tube Length Units Tube Code No. Tube Tube Length
No. Joints (mm) No. Joints (mm)
JQ-730V 1 YK-BF-190 BF 190 MP-730V 1 YK-CO090 CO 90
2 YK-BO180 BO 180 2 YKAO300 AO 300
3 YK-BO160 BO 160 3 YK-BC70 BC 70
4 YK-BF150 BF 150 4 YK-DO240 DO 240
5 †
OO 230 JQ-731V 1 YK-AO230 AO 230
6 YK-AB200 AB 200 MC-730V 1 †
OO 190
7 †
OO 175 2 †
OO 90
8 YK-AB200 AB 200 3 YK-AO080 AO 80
9 YK-BB190 BB 190 4 YK-BO120 BO 120
10 YK-BB220 BB 220 5 †
OO 100
11 †
OO 130 6 †
OO 120
12 †
OO 130 7 YK-AO140 AO 140
13 YK-AO150 AO 150 8 †
OO 110
MJ-730V 1 YK-AB240 AB 240 9 †
OO 190
2 YK-BO250 BO 250 10 YK-AL320 AL 320
3 YK-AO260 AO 260 11 YK-KO210 KO 210
4 YK-BO120 BO 120 12 YK-AO140 AO 140
5 YK-AO250 AO 250 13 YK-KO90 KO 90
6 †
OO 190 14 YK-BO180 BO 180
7 6114-910758 * Pharmed Φ0.51 × 0.9 15 YK-BO240 BO 240
L200 16 YK-AO140 AO 140
8 6114-094961 * Pharmed Φ1 × 3 L100 17 YK-AO170 AO 170
9 †
OO 300 18 YK-AO200 AO 200
10 6114-924208 * Pharmed Φ1 × 3 L260 MP-731V 1 YK-CO60 CO 60
11 YK-AO140 AO 140 2 YK-CO55 CO 55
12 YK-AO230 AO 230 3 YK-BC290 BC 290
13 6114-922781 * Pharmed Φ1.6 × 3.2 4 YK-BC350 BC 350
L280 5 YK-BO85 BO 85
14 YK-DO660 DO 660 MS-730V 1 YK-00016 AC 1140
15 YK-AO130 AO 130 BD 1080
16 YK-AO180 AO 180 MS-731V 1 YK-AB130 AB 130
17 YK-BO400 BO 400 2 YK-AK240 AK 240
18 6114-922763 * Pharmed Φ1.6 × 3.2 MEK-7300 1 YK-BO450 BO 450
L55 2 YKBO390 BO 390
19 6114-142027 * Pharmed Φ1.6 × 3.2 3 †
OO 500
L260 4 YK-AA520 AA 520
20 †
OO 190 5 YK-DH680 DH 680
21 YK-BO220 BO 220 6 YK-AB660 AB 660
22 YK-AB1870 AB 1870 7 YK-AB400 AB 400
23 YK-AB210 AB 210 8 YK-AB480 AB 480
24 †
OO 110 9 YK-AA510 AA 510
25 YK-00017 OC 400 10 YK-AA510 AA 510
26 †
OO 70 11 YK-AO440 AO 440
MJ-730V 27 YK-AO410 AO 410 †
Place an order for NK Code no. YK-00015 and cut it into each
28 YK-BO260 BO 260 suitable length.
29 YK-AB340 AB 340 Note: Set the tube to a cutter. Then rotate the tube and get
30 YK-AB240 AB 240 its cross-section flatly.
31 †
OO 275
Code No. Joints Length
(mm)
YK-00015 OO 1000

24 25
MJ-730V 9 UT-7236 Sensor：2
JQ-730V 7
4
2 25 4
MS-730V 1
ON
8 1 1
ISOTONAC.3
Thermistor 2 2
OFF 1 <10> 10 CLEANAC
3 3
CLEANAC.3
<9>
1st Dilution 5
6
<6> 21 Sensor：1
<8> 30
MC-730V 11
HEMOLYNAC.3N
12
HEMOLYNAC.5
<5> <7>
4 1 Sensor：3
5 2 27
R W Sensor：4
2 3 4
17
12 13 13
Filter 1 9 MS-731V 1 22
WASTE

6 3 Warmer
8 10
26
5 7 8 9
28
2
Hydraulic System Diagram
Filter
3 7
8 7 Filter
11 4 23
14 4
31
2 5 3 4
13 14
15 6
Case 5 6 1 2
9 Pressure
MO-820V
5 19
Sensor 1 2
13 12
18 19 20 18
9
Manifold
16 17 18
12 10 ISO3 HEMO3N HEMO5

7
11
JQ-731V JQ-732V 15 8
MP-731V
10 2
1 1
11
1 2 3 4 5 6
29 3
3
<11>
MP-640V MP-640V 1
14 15 16 17 20
1 2
16
<4>
21 22 23 4
24
<1>
<2> <3> MP-730V
Front Side
2.11
2
Block Diagram

Manufacturer
NIHON KOHDEN CORPORATION
1-31-4 Nishiochiai, Shinjuku-ku
Tokyo 161-8560, Japan
Phone +81 (3) 5996-8036
Fax +81 (3) 5996-8100
Sales
USA Asia
NIHON KOHDEN AMERICA, INC. NIHON KOHDEN TRADING (SHANGHAI)
90 Icon Street, Foothill Ranch, CA 92610, USA CO., LTD
Phone +1 (949) 580-1555 7th Floor, Dawning Centre Tower A No.500
Fax +1 (949) 580-1550 Hongbaoshi Road, Changning District
Shanghai 201103, China
Europe Phone +86 (21) 6270-0909
Fax +86 (21) 6270-9700
European Representative
NIHON KOHDEN EUROPE GmbH Beijing Branch
Room 1701, East Ocean Centre
Raiffeisenstrasse 10
No. 24A JianGuoMenWai Street, Beijing, 100004
D-61191 Rosbach v.d.H., Germany
Phone 010-6515-5750
Phone +49 6003 827-0 Fax 010-6515-5758
Fax +49 6003 827-599
Guangzhou Branch
NIHON KOHDEN ITALIA S.r.l. Room 2514, Yian Plaza
Via Fratelli Bronzetti 28 No. 33 Jian She Liu Ma Road, Guangzhou, 510060
I-24124 Bergamo, Italy Phone 020-8363-3737
Phone +39 035 219 543 Fax 020-8363-3807
Fax +39 035 232 546
NIHON KOHDEN SINGAPORE PTE LTD
NIHON KOHDEN FRANCE SARL 1 Maritime Square, #10-34 (Lobby C), Harbour Front Centre
8, rue Francois Delage, 94230 Cachan, France Singapore 099253
Phone +33 1 49 08 05 50 Phone +65 6376-2210
Fax +33 1 49 08 93 32 Fax +65 6376-2264
NIHON KOHDEN IBERICA S.L. NIHON KOHDEN KOREA, INC.

C/Ulises 75A Hannam Tower Annex Bldg. Suite 203
E-28043 Madrid, Spain 730 Hannam-dong, Yongsan-gu, Seoul, Korea 141-210
Phone +34 917 161 080 Phone +82 (2) 3273-2310
Fax +34 913 004 676 Fax +82 (2) 3273-2352
NIHON KOHDEN UK LTD

Tolworth Tower, Ewell Road, Surbiton Production
Surrey KT6 7EL, UK Reagent Production
Phone +44 20-8390-8622
Fax +44 20-8390-4675 NIHON KOHDEN FIRENZE S.r.l.
Via Torta 72/74
I-50019 Sesto Fiorentino Firenze, Italy
Phone +39 055 3045 1
Fax +39 055 308548
The model and serial number of your instrument are identified on the rear or bottom of the unit.
Write the model and serial number in the spaces provided below. Whenever you call your representative concerning
this instrument, mention these two pieces of information for quick and accurate service.
Model Serial number
Your Representative
PRINTED IN JAPAN

Automated Hematology Analyzer: MEK-7300K

Uploaded by

Copyright:

Available Formats

Automated Hematology Analyzer: MEK-7300K

Uploaded by

Document Information

Original Title

Copyright

Available Formats

Share this document

Share or Embed Document

Sharing Options

Did you find this document useful?

Is this content inappropriate?

Copyright:

Available Formats

Automated Hematology Analyzer: MEK-7300K

Uploaded by

Copyright:

Available Formats

Automated

If you have any comments or suggestions

The contents of this manual are subject to change without notice.

Non-Disclosure Agreement (Sample)

THIS AGREEMENT between (COMPANY) and Nihon Kohden Corporation (NK),

THIS AGREEMENT shall not apply to the following information.

Technical Reference Manual MEK-7300K N.1

Section 1 Replaceable Parts List........................................................... 1.1

Section 2 Cable Wiring and Tube List.................................................... 2.1

Technical Reference Manual MEK-7300K C.1

Technical Reference Manual MEK-7300K 1.1

1.2 Technical Reference Manual MEK-7300K

MEK-7300K UT-7241 MAIN BD

UT-7238 VALVE CONNECTION BD1

UT-7240 VALVE CONNECTION BD3

MC-730V CBC Measuring Unit

UT-7201 HGB AMP BD

UT-7202 HGB LED BD

UT-7249 MEASURING BD (RBC)

UT-7249 MEASURING BD (WBC)

XP-602V 2-way Valve (× 2)

XP-612V 2-way Valve (× 7)

MJ-730V Flow Cytometry Piping Unit

XP-513V 3-way Valve

XP-612V 2-way Valve (× 21)

Technical Reference Manual MEK-7300K 1.3

MO-820V2 LASER OPTICAL UNIT

MF-820V2 FLOWCELL UNIT

MP-640V Pump Unit

MP-640V Pump Unit

MP-730V Mixed Pump Unit

UT-7200 MIXED PUMP BD

XP-513V 3-way Valve

MP-731V Triple Pump Unit

UT-7239 VALVE CONNECTION BD2

XP-503V 3-way Valve (× 2)

MS-730V Sampler Unit

UT-7234 SAMPLER JUNCTION BD

UT-7235 SAMPLER SENSOR BD

MS-731V Cap Pierce Unit

JQ-730V Inlet/Outlet Unit

UT-7236 LIQUID SENSOR BD

XP-612V 2-way Valve (× 4)

1.4 Technical Reference Manual MEK-7300K

XP-612V 2-way Valve

JQ-732V Valve Unit

XP-612V 2-way Valve (× 2)

PV-730VK Front Panel Unit

UT-7248 PRINT KEY BD

UT-7205 PRINTER DRIVER BD

Technical Reference Manual MEK-7300K 1.5

Units and Boards

Rank Index Model Qty Description

1.6 Technical Reference Manual MEK-7300K

Technical Reference Manual MEK-7300K 1.7

Rank Index Model Qty Description

1.8 Technical Reference Manual MEK-7300K

Technical Reference Manual MEK-7300K 1.9

Rank Index Code No. Qty Description

ＮＯ．ａ UT-7242 UT-7241

ＮＯ．ｂ UT-7242 UT-7243

ＮＯ．ｃ UT-7242 UT-7244

ＮＯ．ｄ UT-7241 UT-7243