SAFETY DATA SHEET Page: 1 of 6

Rust Zapper Revision: 05/20/2020

1. Product and Company Identification

Product Code: 891
Product Name: Rust Zapper
Company Name: Balmar, LLC Phone Number:
616 W. Pont Des Mouton Rd. (337)232-2496
Lafayette, LA 70507-4002
Email address: Info@oilcenter.com
Emergency Contact: CHEMTREC 01 (703)527-3887

2. Hazards Identification
Serious Eye Damage/Eye Irritation, Category 2B

GHS Signal Word: Warning

GHS Hazard Phrases: H320 - Causes eye irritation.
GHS Precautionary Phrases: P264 - Wash hands thoroughly after handling.
GHS Response Phrases: P305+351+338 - IF IN EYES: Rinse cautiously with water for several minutes. Remove
contact lenses, if present and easy to do. Continue rinsing.
P337+313 - If eye irritation persists, get medical advice/attention.
GHS Storage and Disposal No phrases apply.
Phrases:
Potential Health Effects Hazards not otherwise classified (HNOC) or not covered by GHS -none.
(Acute and Chronic):
Chronic: None.

Inhalation: No hazard expected in normal industrial use.

Skin Contact: Non-irritating to the skin.
Eye Contact: Non-irritating to the eyes.
Ingestion: No hazard expected in normal industrial use.

3. Composition/Information on Ingredients
CAS # Components (Chemical Name) Concentration
7732-18-5 Water 75.0 - 85.0 %
NA Proprietary chelating agent 10.0 - 20.0 %
NA Proprietary pH Neutralizing agent 5.00 - 10.0 %

MIRS MSDS, (c) A V Systems, Inc. GHS format

 SAFETY DATA SHEET Page: 2 of 6

Rust Zapper Revision: 05/20/2020

4. First Aid Measures

Emergency and First Aid Move out of dangerous area. Consult a physician. Show this safety data sheet to the
Procedures: doctor in attendance.

In Case of Inhalation: No specific treatment is necessary since this material is not likely to be hazardous by
inhalation.
In Case of Skin Contact: No specific treatment is necessary, since this material is not likely to be hazardous. Wash
off with soap and plenty of water.
In Case of Eye Contact: No specific treatment is necessary, since this material is not likely to be hazardous. Rinse
thoroughly with plenty of water for at least 15 minutes and consult a physician.
In Case of Ingestion: No specific treatment is necessary, since this material is expected to be non-hazardous.
Rinse mouth with water. Consult a physician.
Signs and Symptoms Of The most important known symptoms and effects are described in the labelling (see
Exposure: section 2.2) and/or in section 11
Indication of any immediate No data available.
medical attention and special
treatment needed:
Note to Physician: Treat symptomatically and supportively.

5. Fire Fighting Measures

Flash Pt: No data.
Explosive Limits: LEL: No data. UEL: No data.
Autoignition Pt: No data.
Suitable Extinguishing Media: Substance is nonflammable; use agent most appropriate to extinguish surrounding fire.
Fire Fighting Instructions: As in any fire, wear a self-contained breathing apparatus in pressure-demand,
MSHA/NIOSH (approved or equivalent), and full protective gear. Material will not burn.
Wear self contained breathing apparatus for fire fighting if necessary.

Flammable Properties and No data available.

Hazards:
Hazardous Combustion No data available.
Products:

6. Accidental Release Measures

Protective Precautions, Use personal protective equipment. Avoid breathing vapors, mist or gas. For personal
Protective Equipment and protection see section 8.
Emergency Procedures:
Environmental Precautions: Do not let product enter drains. Prevent further leakage or spillage if safe to do so.
Discharge of material must be accordance with local and federal regulations.
Steps To Be Taken In Case Use proper personal protective equipment as indicated in Section 8.
Material Is Released Or Spills/Leaks: Absorb spill with inert material (e.g. vermiculite, sand or earth), then place in
Spilled: suitable container. Pick up and arrange disposal without creating dust. Sweep up and
shovel. Keep in suitable, closed containers for disposal.

7. Handling and Storage

Precautions To Be Taken in No special handling procedures are required. Avoid contact with skin and eyes.
Handling: For precautions see section 2.
Precautions To Be Taken in No special storage requirements. Keep container tightly closed in a dry and
Storing: well-ventilated place.

MIRS MSDS, (c) A V Systems, Inc. GHS format

 SAFETY DATA SHEET Page: 3 of 6

Rust Zapper Revision: 05/20/2020

Non Combustible.
Other Precautions: Apart from the uses mentioned in section 1.2 no other specific uses are stipulated.

8. Exposure Controls/Personal Protection

CAS # Partial Chemical Name OSHA TWA ACGIH TWA Other Limits
7732-18-5 Water No data. No data. No data.

NA Proprietary chelating agent No data. No data. No data.

NA Proprietary pH Neutralizing agent PEL: 2 mg/m3 CEIL: 2 mg/m3 No data.

Respiratory Equipment Respirator protection is not normally required.

(Specify Type):
Eye Protection: Eye protection is not normally required. Splash contact: Safety glasses.
Protective Gloves: Protective garments not normally required. Handle with gloves. Gloves must be inspected
prior to use. Use proper glove removal technique (without touching glove's outer surface)
to avoid skin contact with this product. Dispose of contaminated gloves after use in
accordance with applicable laws and good laboratory practices. Wash and dry hands.
Material: Nitrile rubber Minimum layer thickness: 0.11 mm.
This recommendation is advisory only and must be evaluated by an industrial hygienist
and safety officer familiar with the specific situation of anticipated use by our customers.
It should not be construed as offering an approval for any specific use scenario.
Other Protective Clothing: Protective garments not normally required.
Engineering Controls There are no special ventilation requirements. Handle in accordance with good industrial
(Ventilation etc.): hygiene and safety practice. Wash hands before breaks and at the end of workday.
Environmental Exposure Do not let product enter drains. Prevent further leakage or spillage if safe to do so.
Controls: Discharge of material must be accordance with local and federal regulations.

9. Physical and Chemical Properties

Physical States: [ ] Gas [ X ] Liquid [ ] Solid
Appearance and Odor: Blue.
No apparent odor.
pH: 5-7
Melting Point: No data.
Boiling Point: No data.
Flash Pt: No data.
Evaporation Rate: No data.
Flammability (solid, gas): No data available.
Explosive Limits: LEL: No data. UEL: No data.
Vapor Pressure (vs. Air or No data.
mm Hg):
Vapor Density (vs. Air = 1): No data.
Specific Gravity (Water = 1): 1.078
Density: 9
Solubility in Water: Completely

MIRS MSDS, (c) A V Systems, Inc. GHS format

 SAFETY DATA SHEET Page: 4 of 6

Rust Zapper Revision: 05/20/2020

Octanol/Water Partition No data.

Coefficient:
Autoignition Pt: No data.
Decomposition Temperature: No data.
Viscosity: No data.

10. Stability and Reactivity

Reactivity: No data available.
Stability: Unstable [ ] Stable [ X ]
Conditions To Avoid - No data available.
Instability:
Incompatibility - Materials To Strong oxidizing agents, Strong acids.
Avoid:
Hazardous Decomposition or No data available. In the event of fire: see section 5.
Byproducts:
Possibility of Hazardous Will occur [ ] Will not occur [ X ]
Reactions:
Conditions To Avoid - No data available.
Hazardous Reactions:

11. Toxicological Information

Toxicological Information: Epidemiology: No data available.
Teratogenicity: No data available.
Irritation or Corrosion: Skin corrosion/irritation.

Result: Tumorigenic:Tumors at site or application. Irritating to eyes . Serious eye

damage/eye irritation: Eyes: Rabbit.
Sensitization: Prolonged or repeated exposure may cause allergic reactions in certain sensitive
individuals. Will not occur.
Chronic Toxicological Specific target organ toxicity -single exposure (Globally Harmonized System) No data
Effects: available.
Specific target organ toxicity -repeated exposure: no data available.
Carcinogenicity/Other CAS# 7732-18-5: Not listed by ACGIH, IARC, NTP, or CA Prop 65. IARC: No component
Information: of this product present at levels greater than or equal to 0.1% is identified as probable,
possible or confirmed human carcinogen by IARC.
ACGIH: No component of this product present at levels greater than or equal to 0.1% is
identified as a carcinogen or potential carcinogen by ACGIH.
NTP: No component of this product present at levels greater than or equal to 0.1% is
identified as a known or anticipated carcinogen by NTP.
OSHA: No component of this product present at levels greater than or equal to 0.1% is
identified as a carcinogen or potential carcinogen by OSHA.
CAS # Components (Chemical Name) NTP IARC ACGIH OSHA
7732-18-5 Water n.a. n.a. n.a. n.a.
NA Proprietary chelating agent n.a. n.a. n.a. n.a.
NA Proprietary pH Neutralizing agent n.a. n.a. n.a. n.a.

MIRS MSDS, (c) A V Systems, Inc. GHS format

 SAFETY DATA SHEET Page: 5 of 6

Rust Zapper Revision: 05/20/2020

12. Ecological Information

No data available.
Results of PBT and vPvB PBT/vPvB assessment not available as chemical safety assessment not required/not
assessment: conducted.
Persistence and No data available. The methods for determining the biological degradability are not
Degradability: applicable to inorganic substances.
Bioaccumulative Potential: No data available.
Mobility in Soil: No data available.
Other adverse effects: No data available. An environmental hazard cannot be excluded in the event of
unprofessional handling or disposal. Harmful to aquatic life.

13. Disposal Considerations

Waste Disposal Method: Chemical waste generators must determine whether a discarded chemical is classified as
a hazardous waste. US EPA guidelines for the classification determination are listed in 40
CFR Parts 261. Additionally, waste generators must consult state and local hazardous
waste regulations to ensure complete and accurate classification.
RCRA P-Series: None listed.
RCRA U-Series: None listed. Product.
Offer surplus and non-recyclable solutions to a licensed disposal company. Contact a
licensed professional waste disposal service to dispose of this material.
Contaminated packaging. Dissolve or mix the material with a combustible solvent and
burn in a chemical incinerator equipped with an afterburner and scrubber.

14. Transport Information

LAND TRANSPORT (US DOT):
DOT Proper Shipping Name: Not regulated as a hazardous material
DOT Hazard Class:
UN/NA Number:
LAND TRANSPORT (Canadian TDG):
TDG Shipping Name: No information available.
MARINE TRANSPORT (IMDG/IMO):
IMDG/IMO Shipping Name: Not dangerous goods
AIR TRANSPORT (ICAO/IATA):
ICAO/IATA Shipping Name: Not dangerous goods

15. Regulatory Information

EPA SARA (Superfund Amendments and Reauthorization Act of 1986) Lists
CAS # Components (Chemical Name) S. 302 (EHS) S. 304 RQ S. 313 (TRI)
7732-18-5 Water No No No
NA Proprietary chelating agent No No No
NA Proprietary pH Neutralizing agent No Yes 1000 LB No
This material meets the EPA 'Hazard Categories' defined for SARA Title III Sections 311/312 as indicated:
[ ] Yes [X] No Explosive [ ] Yes [X] No Acute toxicity (any route of exposure)
[ ] Yes [X] No Flammable (gases, aerosols, liquid, or solid) [ ] Yes [X] No Skin Corrosion or Irritation
[ ] Yes [X] No Oxidizer (liquid, solid or gas) [X] Yes [ ] No Serious eye damage or eye irritation
[ ] Yes [X] No Self-reactive [ ] Yes [X] No Respiratory or Skin Sensitization
[ ] Yes [X] No Pyrophoric (liquid or solid) [ ] Yes [X] No Germ cell mutagenicity
[ ] Yes [X] No Pyrophoric gas [ ] Yes [X] No Carcinogenicity
[ ] Yes [X] No Self-heating [ ] Yes [X] No Reproductive toxicity
[ ] Yes [X] No Organic peroxide [ ] Yes [X] No Specific target organ toxicity (single or repeated exposure)

MIRS MSDS, (c) A V Systems, Inc. GHS format

 SAFETY DATA SHEET Page: 6 of 6

Rust Zapper Revision: 05/20/2020

[ ] Yes [X] No Corrosive to metal [ ] Yes [X] No Aspiration Hazard

[ ] Yes [X] No Gas under pressure (compressed gas) [ ] Yes [X] No Simple Asphyxiant
[ ] Yes [X] No In contact with water emits flammable gas [ ] Yes [X] No (Health) Hazard Not Otherwise Classified (HNOC)
[ ] Yes [X] No Combustible Dust
[ ] Yes [X] No (Physical) Hazard Not Otherwise Classified (HNOC)

CAS # Components (Chemical Name) Other US EPA or State Lists

7732-18-5 Water CAA HAP,ODC: No; CWA NPDES: No; TSCA: Yes -
Inventory; CA PROP.65: No; MA Oil/HazMat: No; NJ EHS:
No; NY Part 597: No; PA HSL: No
NA Proprietary chelating agent CAA HAP,ODC: No; CWA NPDES: No; TSCA: Yes -
Inventory; CA PROP.65: No; MA Oil/HazMat: No; NJ EHS:
No; NY Part 597: No; PA HSL: No
NA Proprietary pH Neutralizing agent CAA HAP,ODC: No; CWA NPDES: No; TSCA: Yes -
Inventory; CA PROP.65: No; MA Oil/HazMat: Yes; NJ EHS:
No; NY Part 597: Yes: HS; PA HSL: Yes - E

CAS # Components (Chemical Name) International Regulatory Lists

7732-18-5 Water Canadian DSL: Yes; New Zealand IOC: Yes; REACH: Yes -
(P)
NA Proprietary chelating agent Canadian DSL: Yes; New Zealand IOC: Yes; REACH: Yes -
(R): Full, (P)
NA Proprietary pH Neutralizing agent Canadian DSL: Yes; New Zealand IOC: Yes; REACH: Yes -
(R): Full, (P)

16. Other Information

Revision Date: 05/20/2020

Additional Information About No data available.

This Product:
Company Policy or The information contained here is based upon data available to us and reflects our best
Disclaimer: professional judgment. Since it is impossible to anticipate the conditions under which our
products may be used, we cannot guarantee that the recommendations will be adequate
for all individuals and situations. Each user of this product should determine the suitability
of the product with zero or minimum hazards. Our products are improved daily as
up-to-date information and research data is recieved from our suppliers in our quest to
use products with less or no hazards. Please feel free to contact us for current
information.

MIRS MSDS, (c) A V Systems, Inc. GHS format