SERVICE MANUAL

MCD-510

MODEL NO.:MCD-510

Contents
Specification 1-3
Block Diagram 4
Packing View 5
Packing View Part List 6
Point To Point Wiring Diagram 7
Exploded View 8
Exploded View Part List 9-10
Electrical Part List 11-21
Schematic Diagram 22-25
Printed Circuit Board Diagram 26-32
IC Block Diagram 33-42
Trouble Shooting 43
General Specification
1. MODEL MCD-510, Dual CD/MP3 player with wired remote control.

2. POWER SOURCE AC 115/230V, 50/60Hz, 24Watts

3. DIMENSIONS Main Unit 482(W)x 88.8(H)x 262(D)mm

Control Unit 482(W)x 88.8(H)x 96(D)mm

4. WEIGHT 6.38 Kgs

5. FEATURES

6. AUDIO CHARACTERISTICS (TEST DISC: TCD-782, LOAD=47KOHM)

ITEM TYPICAL LIMIT CONDITION
(1) OUTPUT LEVEL 2VRMS +/-0.5dB 2VRMS +/-1dB 1KHz, 0dB
(2) CHANNEL BALANCE WITHIN 0.2dB WITHIN 1dB 1KHz, 0dB
(3) FREQUENCY RESPONSE 20-20KHz +/-0.4dB 20-20KHz +/-1dB 0dB OUTPUT
(4) DE-EMPHASIS +2.4/-0dB +3/-0dB 16KHz,-20dB
(5) CHANNEL SEPARATION (*2) 100dB 90dB 1KHz, 0dB
(6) THD+N (*1) 0.01% 0.01% 1KHz, 0dB
(7) S/N (*2) 102dB 90dB 1KHZ, 0dB
Note: *1: WITH 20KHz LOW PASS FILTER.*2: WITH 20KHz LOW PASS FILTER AND "IHF-A" WEIGHTED.

6-2 MP3(TEST DISC:TCD-MP3, LOAD = 47KOHM)

ITEM TYPICAL LIMIT CONDITION
(1) OUTPUT LEVEL 2V+/-1dB 2V+/-1dB TCD-MP3 NO.1
(2) S/N (*2) 101dB 90dB TCD-MP3 NO.2
(3) R CHANNEL SEPARATION (*2) 100dB 90dB TCD-MP3 NO.3
(4) L CHANNEL SEPARATION (*2) 100dB 90dB TCD-MP3 NO.4
(5) THD+N(*1) 0.03% 0.07% TCD-MP3 NO.1

7. SEARCHING TIME (TEST DISC: TCD-792)

ITEM TYPICAL LIMIT CONDITION
(1) SHORT ACCESS TIME 2Sec 4Sec PLAY NEXT TRACK
(2) LONG ACCESS TIME 4Sec 6Sec TRACK 1 TO 20,20 TO 1

8. PLAYABILITY
ITEM TYPICAL LIMIT CONDITION
(1) INTERRUPTION 1mm 0.7mm TCD-725
(2) BLACK DOT 1mm 0.6mm TCD-725
(3) FINGER PRINTS 75um 65um TCD-725
(4) ECCENTRICITY 140um 140um TCD-712 W/O TRACK JUMP
(5) VERTICAL DEVIATION 1mm 0.5mm TCD-731R

9. FUNCTION SWITCHES
MAIN UNIT
NAME Q’TY TYPE NOTE
(1) POWER 1 PUSH
(2) OP/CL 2 TACT

1
General Specification
CONTROL UNIT
NAME Q’TY TYPE NOTE
(1) PLAY/PAUSE 2 TACT
(2) CUE 2 TACT
(3) +-10 TRACKS SKIP 4 TACT
(4) F.SKIP/B.SKIP 4 TACT
(5) REV/FWD 2 TACT
(6) FRAME SEARCH 2 JOG WHEEL
(7) SINGLE/CONTINUE 2 TACT
(8) TIME 2 TACT
(9) PITCH ON/OFF 2 TACT
(10)PITCH BEND 4 TACT
(11)PITCH 2 6cm SLIDE VR
(12)OPEN/CLOSE 2 TACT
(13)PITCH RANGE 2 TACT
(14)LOOP IN/OUT/RELOOP 6 TACT

10. PICK-UP (SONY KSM-213VCS)

(1) System Object lens drive system optical pick-up
(2) Object lens drive system 2 dimensional parallel drive
(3) Tracking detection 3 spot beam detection
(4) Optical source Semiconductor laser
(5) Wave length 780nm

11. GENERAL
(1) System Compact Disc Digital Audio
(2) Disc loading Front loading
(3) Display 11 Digital LCD Display
(4) Pitch control range Within +/-4%,+/-8%,+/-16%
(5) Pitch bend +/-16%
(6) Pitch accuracy 0.1%
(7) Digital out level 0.5V+/-0.1V p-p @ LOAD = 75 ohm (option)

12. ENVIRONMENTAL CONDITION

(1) Operating Temperature 5 to 35 deg. C
(2) Humidity 25 to 85% RH (non-condensing)
(3) Storage Temperature -20 to 60 deg. C

13. ACCESSORIES
(1) Pin-connected cord L/R 2 pairs
(2) Remote connecting cable 1 pc (3M)
(3) Operating Instruction 1 pc

14. NOTES
(1) The specifications are subject to change to any improvement by negotiations in advance.
(2) The parts are subject to change to any improvement within the range of the specifications.

2
General Specification
15. MP3 FORMAT
Applicable file extensions mp3 . MP3 . mP3 . Mp3
Disc Format
ISO9660 Level 1(max. 8/”8.3” character style)
Level 2(max. 31/30 character style)
Joliet max. 64/64 character style
CD-ROM sector format mode-1 only
Max. number of Folders 255
Max. number of files max. 999 files (* note #1)
MPEG 1 Layer 3 standard (ISO/IEC
11172-3), which provides for single
channel
(‘mono’) and two-channel (‘stereo’)
coding at sampling rates of 32, 44.1
and 48kHz.

MP3 Format MPEG 2 Layer 3 standard (ISO/IEC

13818-3), which provides for similar
coding at sampling rates of 16,
22.05 and 24 kHz.
MPEG 2.5 Layer 3 standard, which
provides for similar coding at
sampling rates of 8, 11.025 and 12
kHz.
Disc at Once and Track at Once
st
Disc Writing Method If the 1 session is CDDA, you can playback
Multi Session Only CDDA track, If the 1st session is
MP3, you can playback only MP3 file.
Note #1: mdx.255 files each folder

3
 1 2 3 4
CONTROL PCB
LED PHOTO
INTERRUPTER
D KEY & SWITCH FADER D

1
TMP86P202 2
LED SLAVE CPU
1 2
74595

3
LED DRIVER
SM8958A BU9728 LCD
UI MAIN CPU LCD DRIVER
PLAY CONTROL
LOADER
DRIVE UNIT SERVO PCB DSP PCB
D.OUT PCB
C DISC SLED C
+ +
M M BA5979
DIGITAL OUT
DRIVER
- - 4641632 29LV160
RAM ROM
CD PICK UP
FOCUS
AMP & LPF
15218

4
TRACKING
MCF5249 PCM1716
CXA2581 CXD3068 FX DSP DAC
AUDIO OUT
CD ASP CD DSP
+
B SWITCHES B
M BA6218 SM8952 XC9536
DRIVER SERVO CPU CPLD
-
LOADING
POWER PCB
7V
POWER SWITCH
1 2 5V
POWER SUPPLY 3.3V
A AC CORD A
POWER TRANS. Title
Block Diagram

MCD-510
-5V
Size Number Revision
BLOCK DIAGRAM 0.1
B
Date: 20-May-2005 Sheet of
File: G:\share\BLK.DDB Drawn By: LEC
1 2 3 4
Packing View

6
5
4

9
8
3

10
1

5
Packing View Part List

NO. PART NAME Q'TY M PART NO.

1 MAIN SET POLYFOAM 2 506-HDJ200-138A
2 POLY BAG 1 505-HDJ7000-080
3 SOFT SHEET BUBBLE BAG 1 509-HV3420K-070
4 CONTROLLER SET POLYFOAM 2 506-HDJ200-139
5 SOFT SHEET 1 509-HDJ7000-084
6 SERIES NO. LABEL 0 501-DV300-1067
7 I/B ASS’Y 1 701-510A-3463
8 8P CABLE RIGHTANGLE(L=3000mm) 1 404-HDJ7000-005
9 AC POWER CORD (UL TYPE,L=1900+/-50mm) 1 409-DJ2-070A
10 GIFT BOX 1 507-510-1801

6
 W08A W08
MECHA ASS'Y MECHA ASS'Y

KNOB PCB

CN02
CN03
TO:
POWER
KNOB
Point to Point Wiring Diagram

CN01

CN06
CN06
CD2 SERVO PCB CD1 SERVO PCB

CN03
CN03
POWER PCB

CN01 CN01

CN02
CN02

7
CN01 CN01

Black
CN01 CN01

Yellow
CN03 CN03
Brown

Red
Red

A AC AC K

BUFFER PCB CN301 BUFFER PCB CN301

W09 CN09

CN02
CN02

CN07
CN07

AC JACK ASS'Y
JK301 JK301
Exploded View

8
Exploded View Part List

REF NO. DESCRIPTION PART NO. Q'TY REMARK

1 MAIN FRONT PANEL ASS'Y(AL) 703-MCD510-918 1
2 CD1 SERVO PCB ASS'Y 704-M510-5513 1
3 CD2 SERVO PCB ASS'Y 704-M510-5515 1
4 D-OUT PCB ASS'Y 704-DCD310-5482 2
5 SW PCB ASS'Y 704-DCD310-5539 1
6 AC JACK ASS'Y 704-DJ100-2571 1
7 MECHA ASS'Y 704-HDJ2110-5309 2
8 POWER PCB ASS'Y 704-P22NS-5465 1
9 CD DOOR 100-M510A-1336 2
10 POWER KNOB 100-HDJ200-984 1
11 POWER SW PROTECTOR(PLASTIC) 100-HDJ2400-1300 1
12 JACKET 100-MPCD4-2284 2
13 SLEEVE 200-HDJ7000-256 2
14 BRACKET TRANSFORMER 300-DV300B-443 2
15 MAIN UNIT COVER 300-HDJ200-342A 1
16 POWER SWITCH BRACKET 300-HDJ7000-478 1
17 MAIN UNIT BOTTOM 300-HDJ7000-479 1
18 MAIN UNIT REAR PANEL(1t) 300-MCD510-526K 1
19 POWER SW(SDDLB1017U-HF,2PIN) 403-A100-005 1
20 SLIDE SW(L21-22A8,6PIN) 403-HS100-042 1
21 TRANSFORMER(AC115/230V) 411-2450-441 1
22 STICKER(CLASS 1)(58*26mm,t=0.08mm) 501-1420SRD-867 1
23 LABEL(BARE,36*8mm,t=1.2mm) 501-DV300-1067 0
24 RATING LABEL(40*20mm,t=0.08mm) 501-M510A-1338 1
25 FUSE LABEL(46*6mm,t=0.08mm) 501-PRODJ2-1298 1
26 CNR COVER(HU-12-ULY) 504-CDC2050-105 1
27 ADHESIVE BACKED MOUNTS 504-DJ2500J-047 1
28 BOARD SUPPORT 504-HDJ7000-031 6
29 NUT(4mm,P=0.7 ISO) 601-F200-001 2
30 SCREW(3*8mm BTP) 602-2002-077 23
31 SCREW(M3*8,P=0.5,BLACK) 602-2002-085 6
32 SCREW(PTB,∮3*8,ZB) 602-DJ5500-452 6
33 SCREW(WPTP,∮2.6*7,CAP10,ZMC) 602-DV300-5023 2
34 SCREW(4*6mm TTB BLACK) 602-HDJ200-214 4
35 SCREW(W.STN,4*10,ZS) 602-HDJ9700-426 2
36 SCREW(M3*P0.5*L8) 602-HP1010K-178 2
37 SCREW(3*5mm,BLACK) 602-KE200-145 25
38 MAIN UNIT BUTTON 604-7500NSA3-137 1
39 WASHER 606-B300-039 2
40 SPRING 606-STR830-141 2
41 MAT FORBASE 612-HDJ201-053 4
42 CONTROLLER FRONT PANEL ASS'Y(AL) 703-MCD510-915 1
43 SENSOR PCB ASS'Y 704-DCD310-5478 2
44 CONTROL PCB ASS'Y 704-M510-5510 1

9
Exploded View Part List

REF NO. DESCRIPTION PART NO. Q'TY REMARK

45 FRAME ASS'Y 701-MCD510-3433 2
46 SHUTTLE TURNING KNOB 701-MCD810-3455 2
47 CONTROLER PITCH KNOB 100-HDJ7000-985 2
48 FOOT ( PVC ) 100-HDJ7000-1235 4
49 SENSOR PLATE 100-MCD810-2287 2
50 CONTROL UNIT SIDE BOARD 300-HDJ5000-496 2
51 CONTROL UNIT REAR COVER 300-MCD510-497C 1
52 DECORATIONS 501-HDJ2400-1160 2
53 PLASTIC SCREW(S-306-N66) 602-SPANDMK2-536 12
54 SCREW(W BTP 3*12L) 602-HDJ7000-256 4
55 SCREW 602-HMD510B-198 4
56 SCREW(M2.6*8,BLACK) 602-MCD810-555 2
57 SCREW(2.6*8 PTP) 602-SL24F-099 20
58 OP/CL SILICON BUTTON 604-MCD510-337 2
59 RELAY SILICON BUTTON 604-MCD510-338 1
60 MAIN KNOB(SILICA) 604-MCD510-336 2
61 E RING 606-DJ3000-105 2
62 PULLEY WASHER 606-F200-003 2
63 WASHER(∮2.6) 606-MCD810-204 2
64 WASHER(∮8*2.8*0.5t) 606-MCD810-205 2
65 VR CUSHION(75.5*8.5*0.3t) 612-HDJ7000-056A 2
66 AC POWER CORD( L=1900+-50mm,UL TYPE ) 409-DJ2-070A 1
67 SPACER SUPPORT(H-20) 504-RMX30-157 6
68 BUFFER PCB ASS'Y 704-M510-5516 2

10
CD1 SERVO P.C.B ASS'Y PART LIST

REF NO. DESCRIPTION PART NO. Q'TY REMARK

CD1 SERVO PCB ASS'Y 704-M510-5513 1
JK102 DIN SOCKET SUPPORT BRACKET 300-HDJ7000-473 1
CN03 5P SOCKET(B5B-PH-K,P=2mm,JST,180 DEGREE)(Pb,Cd) 404-1210S-094 1
CN02 6P SOCKET((B6B-PH-K-S,P=2mm,JST,180 DEGREE) 404-3113-052 1
CN01 16P FFC CONNECTOR(P=1.0mm,16PIN)(Pb,Cd) 404-HDJ201-599 1
CN09A 3P SOCKET(B3B-XH-A,P=2.5mm,JST,180 DEGREE) 404-HV3500K-623 1
CN06 3P SOCKET(CKM2501WR-3P 90°WHITE)(Cd,Pb,Hg,Cr) 404-KMD3500-609A 1
IC103 IC SOCKET(PLCC-44) 404-MPG100-384 1
CN07 8P CONNECTOR WIRE 404-RCC1055-1569 1
J78(20mm) JUMPER 406-3113-175 1
RB101 THICK FILM RESISTOR NETWORKS(10K OHM,1/8W J,RA TYPE,7R8P) 412-DJ1-420 1
C101,C108,C102 ELEC. CAPACITOR(100uF/10V,M,105℃,TAPING 5*11)(Cd,Pb,Hg,Cr) 413-3113-046 3
J72 BEAD CORE(86-019-A TAPING) 415-HV3500K-090 1
IC106 IC(BA5979S,DIP-32) 417-DCM280-596 1
IC107 REVERSIZLE MOTOR DRIVER(BA6218/BA6418N) 417-KC720-049 1
JK101 2P RCA JACK(RJ-1078B-10-0320A) 420-HDJ7000-045 1
JK102 8P DIN JACK(MDJ18-08) 420-HDJ7000-046A 1
CN04*2 6P STRIP PIN HEADER(L=31mm,P=2.54mm,180 DEGREES) 424-HDJ7500-058 2
CN05 11P2.54 STRIP PIN HEADER(L=31mm,180°) 424-T2-075 1
IC106 HEAT SINK 425-CDN88A3-066 1
X102 QUARTZ CRYSTAL(24MHz) 427-DRM120-095 1
X101 CRYSTAL(33.8688MHZ) 427-DV330-043 1
SPACER SUPPORT(H-20) 504-RMX30-157 3
PLASTIC SCREW(S-306-N66) 602-SPANDMK2-536 6
IC106 CLIP FOR HEAT SINK 603-CDN88-291 2
C115,C177,C178 CERAMIC CAPACITOR(1000PF/50V,K,TAPING,Y5P) 413-1430-071 3
C171,C172 CERAMIC CAPACITOR(180pF/50V,K,TAPING,Y5P) 413-3113-030 2
C110,C112,C145,C146,C147 CERAMIC CAPACITOR(220pF/50V,K,TAPING,Y5P) 413-3113-032 5
C103,C105,C106,C111,
C113,C114,C127,C128,
C142,C143,C144,C163,
CERAMIC CAPACITOR(0.1uF/50V,Z,TAPING,Y5V) 413-3113-035 13
C176
C126,C104,C109,C130,C179 ELEC. CAPACITOR(100uF/10V,M,105℃,TAPING 5*11)(Cd,Pb,Hg,Cr) 413-3113-046 5
C181,C182,C107,C140,C1
61,C165,C166,C167,C168 ELEC. CAPACTIOR(10uF/25V,M,105℃,TAPING 5*11)(Cd,Pb,Hg,Cr) 413-3113-052 9
C125 POLYESTER CAPACITOR(0.01uF/50V,J,TAPING) 413-3113-057 1
C122,C169,C170 POLYESTER CAPACITOR(0.0015uF/50V,J,TAPING) 413-HT7016-219 3
C135,C137,C160,C162 ELEC. CAPACITOR(220uF/10V,M,105℃,TAPING 6.3*11)(Cd,Pb,Hg,Cr 413-KC220-119 4
C121 POLYESTER CAPACITOR(0.047uF/50V,J,TAPING) 413-KT300-099 1
C132 POLYESTER CAPACITOR(0.0033uF/100V,J,TAPING) 413-KT300-103 1
C124 ELEC. CAPACITOR(0.47uF/50V,M,105℃,TAPING 5*11)Cd,Pb,Hg,Cr) 413-KT350-093 1
Q101 TRANSISTOR( 2SA933SR TAPING OR 2SA608G) 416-3113-008 1
Q105,Q106 TRANSISTOR(2SD1468 TAPING) 416-3113-009 2
Q102 TRANSISTOR(DTA124ES TAPING OR 2SA1346) 416-KC710-038 1
Q104 TRANSISTOR(DTA124TS/2SA1589/DTA124TSATP,TAPING) 416-KE200S-024 1

11
CD1 SERVO P.C.B ASS'Y PART LIST

REF NO. DESCRIPTION PART NO. Q'TY REMARK

R110,R134, CARBON FILM RESISTOR(150K OHM,1/6W,J,T-26) 412-3113-046 2
R107,R112,R131,R159,R160,R170 CARBON FILM RESISTOR(100K OHM,1/6W,J,T-26) 412-3113-047 6
R108 CARBON FILM RESISTOR(2.2K OHM,1/6W,J,T-26) 412-3113-048 1
R101,R102 CARBON FILM RESISTOR(12K OHM,1/6W,J,T-26) 412-3113-051 2
R113,R114,R129 CARBON FILM RESISTOR(15K OHM,1/6W,J,T-26) 412-3113-053 3
R109 CARBON FILM RESISTOR((27K OHM,1/6W,J,T-26) 412-3113-054 1
R155,R156 CARBON FILM RESISTOR(4.7K OHM,1/6W,J,T-26) 412-3113-055 2
R104 CARBON FILM RESISTOR(470 OHM,1/6W,J,T-26) 412-3113-056 1
R117 CARBON FILM RESISTOR((3.3K OHM,1/6W,J,T-26) 412-3113-057 1
R197,R198,R123,R125,R1
26,R143,R173,R174,R175, CARBON FILM RESISTOR(220 OHM,1/6W,J,T-26) 412-3113-058 11
R176,R177
R185,R186,R187,R188,R1
89,R190,R191,R192,R193, CARBON FILM RESISTOR(100 OHM,1/6W,J,T-26) 412-3113-060 12
R194,R195,R196

R105 CARBON FILM RESISTOR(120K OHM,1/6W,J,T-26) 412-3113-062 1

R130,R135,R136,R137 CARBON FILM RESISTOR((47K OHM,1/6W,J,T-26) 412-3113-063 4
R119,R138,R153,R154 CARBON FILM RESISTOR(10K OHM,1/6W,J,T-26) 412-3113-068 4
R163,R164 CARBON FILM RESISTOR((2.7K OHM,1/6W,J,T-26) 412-3113-073 2
R118,R133,R161,R162 CARBON FILM RESISTOR(1K OHM,1/6W,J,T-26) 412-3113-078 4
R132 CARBON FILM RESISTOR(30K OHM,1/6W,J,T-26) 412-DV300-291 1
R106 CARBON FILM RESISTOR(4.3K OHM,1/6W,J,T-26) 412-HC1421FR-245 1
R103 CARBON FILM RESISTOR(15 OHM,1/6W,J,T-26) 412-HDJ7150-709 1
R124,R142,R184 CARBON FILM RESISTOR(10 OHM,1/6W,J,T-26) 412-KC220-132 3
R183 CARBON FILM RESISTOR(470K OHM,1/6W,J,T-26) 412-KT300-108 1
R141 CARBON FILM RESISTOR((560 OHM,1/6W,J,T-26) 412-KT346-112 1
R169 CARBON FILM RESISTOR(27 OHM,1/4W,J,T-52) 412-PRODJ1-451 1
R157,R158 CARBON FILM RESISTOR(20K OHM,1/6W,J,T-26) 412-STR880-482 2
D101,D103,D104 SWITCHING DIODE(1SS132/1SS133,300mw,55V,T-77) 414-3113-005 3
ZD101 ZENER DIODE(MTZJ5.1-B,1/2W,T-77) 414-HDJ200-056 1
L105,L109 BEAD CORE(86-019-A TAPING) 415-HV3500K-090 2
L101,L103,L104,L107,L108 INDUCTOR(10uH TAPING 52mm) 415-MPG100-047 5
L102 MICRO INDUCTOR(33uH) 415-RCC955A-094 1
SERVO PCB 405-MCD2450-1238 1
R181 CHIP RESISTOR(220K OHM,1/8W,0805,J,TP ,150V) 412-DFX1-569 1
R121,R171,R178 CHIP RESISTOR(10K OHM,1/8W,0805,J,TP 150V) 412-DV330-306 3
R122 CHIP RESISTOR(100K OHM,1/8W, 0805,J,TP 150V) 412-DV330-307 1
R139,R116 CHIP RESISTOR(1M OHM,1/8W, 0805,J,TP 150V) 412-DV330-308 2
R111 CHIP RESISTOR(33K OHM,1/8W,0805,J,TP 150V) 412-DV330-318 1
R199 CHIP RESISTOR( 220 OHM,1/8W,0805,J,TP 150V ) 412-DV330-333 1
R120 CHIP RESISTOR(820K OHM,1/8W,0805,J,TP ,150V) 412-HDJ11-712 1
R179 CHIP RESISTOR (1.5K OHM,1/8W, 0805,J,TP,150V ) 412-QMX1-035 1
R115,R182 CHIP RESISTOR((470K OHM,1/8W, 0805,J,TP 150V) 412-QMX2-120 2
R180 CHIP RESISTOR (470 OHM,1/8W, 0805,J,TP,150V) 412-VCDG3-395 1
C123 CHIP CAPACITOR(220pF/50V,J,0805 TYPE,NPO) 413-AMC110D-5104 1

12
CD1 SERVO P.C.B ASS'Y PART LIST

REF NO. DESCRIPTION PART NO. Q'TY REMARK

C139 CHIP CAPACITOR(100pF/50V,J,0805 TYPE,NPO) 413-DV330-310 1
C164,C183,C184,C116,C1
17,C118,C129,C131,C134, CHIP CAPACITOR(0.1uF/ 50V,Z,0805 TYPE,Y5V) 413-DV330-313 12
C136,C138,C141
C174,C175 CHIP CAPACITOR(20pF/ 50V,J,0805 TYPE,NPO) 413-DV330-315 2
C120 CHIP CAPACITOR(5pF/50V,J,0805 TYPE,NPO) 413-DV330-325 1
C133 CHIP CAPACITOR(0.068uF) 413-SMX701-755 1
IC105 IC(PCM1716E,28PIN,SOP) 417-DCM270X-327A 1
IC102 IC(CXD3068Q,QFP-80,SMD) 417-DCM280-587 1
IC101 IC(CXA-2581N,SSOP-30,SMD) 417-DCM280-588 1
IC108 IC(BA15218F/BA15218FE2,SOP-8) 417-QMX2-167 1
IC103 SERVO IC ASS'Y(CHECK SUM:A21D/23) 704-M510-5514 1
IC(SM8952AC25J,PLCC-44) 417-HDJ2450-693C 1

13
CD2 SERVO P.C.B ASS'Y PART LIST

REF NO. DESCRIPTION PART NO. Q'TY REMARK

CD2 SERVO PCB ASS'Y 704-M510-5515 1
CN03 5P SOCKET(B5B-PH-K,P=2mm,JST,180 DEGREE)(Pb,Cd) 404-1210S-094 1
CN02 6P SOCKET((B6B-PH-K-S,P=2mm,JST,180 DEGREE) 404-3113-052 1
CN01 16P FFC CONNECTOR(P=1.0mm,16PIN)(Pb,Cd) 404-HDJ201-599 1
CN06 3P SOCKET(CKM2501WR-3P 90°WHITE)(Cd,Pb,Hg,Cr) 404-KMD3500-609A 1
IC103 IC SOCKET(PLCC-44) 404-MPG100-384 1
CN07 8P CONNECTOR WIRE 404-RCC1055-1569 1
W09 3P2.5 CONNECTOR WIRE(L=220mm,AWM1007 AWG26) 404-ST150-1720 1
J78(20mm) JUMPER 406-3113-175 1
RB101 THICK FILM RESISTOR NETWORKS(10K OHM,1/8W J,RA TYPE,7R8P) 412-DJ1-420 1
C101,C108,C102 ELEC. CAPACITOR(100uF/10V,M,105℃,TAPING 5*11)(Cd,Pb,Hg,Cr) 413-3113-046 3
IC106 IC(BA5979S,DIP-32) 417-DCM280-596 1
IC107 REVERSIZLE MOTOR DRIVER(BA6218/BA6418N) 417-KC720-049 1
JK101 2P RCA JACK(RJ-1078B-10-0320A) 420-HDJ7000-045 1
CN04 6P STRIP PIN HEADER(L=31mm,P=2.54mm,180 DEGREES) 424-HDJ7500-058 2
CN05 11P2.54 STRIP PIN HEADER(L=31mm,180°) 424-T2-075 1
IC06 HEAT SINK 425-CDN88A3-066 1
X102 QUARTZ CRYSTAL(24MHz) 427-DRM120-095 1
X101 CRYSTAL(33.8688MHZ) 427-DV330-043 1
SPACER SUPPORT(H-20) 504-RMX30-157 3
PLASTIC SCREW(S-306-N66) 602-SPANDMK2-536 6
IC106 CLIP FOR HEAT SINK 603-CDN88-291 2
C115,C177,C178 CERAMIC CAPACITOR(1000PF/50V,K,TAPING,Y5P) 413-1430-071 3
C171,C172 CERAMIC CAPACITOR(180pF/50V,K,TAPING,Y5P) 413-3113-030 2
C110,C112,C145,C146,C147 CERAMIC CAPACITOR(220pF/50V,K,TAPING,Y5P) 413-3113-032 5
C103,C105,C106,C111,
C113,C114,C127,C128,
C142,C143,C144,C163,
CERAMIC CAPACITOR(0.1uF/50V,Z,TAPING,Y5V) 413-3113-035 13
C176

C126,C104,C109,C130,C179 ELEC. CAPACITOR(100uF/10V,M,105℃,TAPING 5*11)(Cd,Pb,Hg,Cr) 413-3113-046 5

C181,C182,C107,C140,C1
61,C165,C166,C167,C168 ELEC. CAPACTIOR(10uF/25V,M,105℃,TAPING 5*11)(Cd,Pb,Hg,Cr) 413-3113-052 9

C125 POLYESTER CAPACITOR(0.01uF/50V,J,TAPING) 413-3113-057 1

C122,C169,C170 POLYESTER CAPACITOR(0.0015uF/50V,J,TAPING) 413-HT7016-219 3
C135,C137,C160,C162 ELEC. CAPACITOR(220uF/10V,M,105℃,TAPING 6.3*11)(Cd,Pb,Hg,Cr 413-KC220-119 4
C121 POLYESTER CAPACITOR(0.047uF/50V,J,TAPING) 413-KT300-099 1
C132 POLYESTER CAPACITOR(0.0033uF/100V,J,TAPING) 413-KT300-103 1
C124 ELEC. CAPACITOR(0.47uF/50V,M,105℃,TAPING 5*11)Cd,Pb,Hg,Cr) 413-KT350-093 1
Q101 TRANSISTOR( 2SA933SR TAPING OR 2SA608G) 416-3113-008 1
Q105,Q106 TRANSISTOR(2SD1468 TAPING) 416-3113-009 2
Q102 TRANSISTOR(DTA124ES TAPING OR 2SA1346) 416-KC710-038 1
Q104 TRANSISTOR(DTA124TS/2SA1589/DTA124TSATP,TAPING) 416-KE200S-024 1
R110,R134 CARBON FILM RESISTOR(150K OHM,1/6W,J,T-26) 412-3113-046 2
R107,R112,R131,R159,R160,R170 CARBON FILM RESISTOR(100K OHM,1/6W,J,T-26) 412-3113-047 6

14
CD2 SERVO P.C.B ASS'Y PART LIST

REF NO. DESCRIPTION PART NO. Q'TY REMARK

R108 CARBON FILM RESISTOR(2.2K OHM,1/6W,J,T-26) 412-3113-048 1
R101,R102 CARBON FILM RESISTOR(12K OHM,1/6W,J,T-26) 412-3113-051 2
R113,R114,R129 CARBON FILM RESISTOR(15K OHM,1/6W,J,T-26) 412-3113-053 3
R109 CARBON FILM RESISTOR((27K OHM,1/6W,J,T-26) 412-3113-054 1
R155,R156 CARBON FILM RESISTOR(4.7K OHM,1/6W,J,T-26) 412-3113-055 2
R104 CARBON FILM RESISTOR(470 OHM,1/6W,J,T-26) 412-3113-056 1
R117 CARBON FILM RESISTOR((3.3K OHM,1/6W,J,T-26) 412-3113-057 1
R197,R198,R123,R125,R1
26,R143,R173,R174,R175, CARBON FILM RESISTOR(220 OHM,1/6W,J,T-26) 412-3113-058 11
R176,R177
R185,R186,R187,R188,R1
89,R190,R191,R192,R193, CARBON FILM RESISTOR(100 OHM,1/6W,J,T-26) 412-3113-060 12
R194,R195,R196

R105 CARBON FILM RESISTOR(120K OHM,1/6W,J,T-26) 412-3113-062 1

R130,R135,R136,R137 CARBON FILM RESISTOR((47K OHM,1/6W,J,T-26) 412-3113-063 4
R119,R138,R153,R154 CARBON FILM RESISTOR(10K OHM,1/6W,J,T-26) 412-3113-068 4
R163,R164 CARBON FILM RESISTOR((2.7K OHM,1/6W,J,T-26) 412-3113-073 2
R118,R133,R161,R162 CARBON FILM RESISTOR(1K OHM,1/6W,J,T-26) 412-3113-078 4
R132 CARBON FILM RESISTOR(30K OHM,1/6W,J,T-26) 412-DV300-291 1
R106 CARBON FILM RESISTOR(4.3K OHM,1/6W,J,T-26) 412-HC1421FR-245 1
R103 CARBON FILM RESISTOR(15 OHM,1/6W,J,T-26) 412-HDJ7150-709 1
R124,R142,R184 CARBON FILM RESISTOR(10 OHM,1/6W,J,T-26) 412-KC220-132 3
R183 CARBON FILM RESISTOR(470K OHM,1/6W,J,T-26) 412-KT300-108 1
R141 CARBON FILM RESISTOR((560 OHM,1/6W,J,T-26) 412-KT346-112 1
R169 CARBON FILM RESISTOR(27 OHM,1/4W,J,T-52) 412-PRODJ1-451 1
R157,R158 CARBON FILM RESISTOR(20K OHM,1/6W,J,T-26) 412-STR880-482 2
D101,D103,D104 SWITCHING DIODE(1SS132/1SS133,300mw,55V,T-77) 414-3113-005 3
ZD101 ZENER DIODE(MTZJ5.1-B,1/2W,T-77) 414-HDJ200-056 1
L105,L109 BEAD CORE(86-019-A TAPING) 415-HV3500K-090 2
L101,L103,L104,L107,L108 INDUCTOR(10uH TAPING 52mm) 415-MPG100-047 5
L102 MICRO INDUCTOR(33uH) 415-RCC955A-094 1
SERVO PCB 405-MCD2450-1238 1
R181 CHIP RESISTOR(220K OHM,1/8W,0805,J,TP ,150V) 412-DFX1-569 1
R121,R171,R178 CHIP RESISTOR(10K OHM,1/8W,0805,J,TP 150V) 412-DV330-306 3
R122 CHIP RESISTOR(100K OHM,1/8W, 0805,J,TP 150V) 412-DV330-307 1
R139,R116 CHIP RESISTOR(1M OHM,1/8W, 0805,J,TP 150V) 412-DV330-308 2
R111 CHIP RESISTOR(33K OHM,1/8W,0805,J,TP 150V) 412-DV330-318 1
R199 CHIP RESISTOR( 220 OHM,1/8W,0805,J,TP 150V ) 412-DV330-333 1
R120 CHIP RESISTOR(820K OHM,1/8W,0805,J,TP ,150V) 412-HDJ11-712 1
R179 CHIP RESISTOR (1.5K OHM,1/8W, 0805,J,TP,150V ) 412-QMX1-035 1
R115,R182 CHIP RESISTOR((470K OHM,1/8W, 0805,J,TP 150V) 412-QMX2-120 2
R180 CHIP RESISTOR (470 OHM,1/8W, 0805,J,TP,150V) 412-VCDG3-395 1
C123 CHIP CAPACITOR(220pF/50V,J,0805 TYPE,NPO) 413-AMC110D-5104 1
C139 CHIP CAPACITOR(100pF/50V,J,0805 TYPE,NPO) 413-DV330-310 1
C164,C183,C184,C116,C1
17,C118,C129,C131,C134, CHIP CAPACITOR(0.1uF/ 50V,Z,0805 TYPE,Y5V) 413-DV330-313 12
C136,C138,C141

15
CD2 SERVO P.C.B ASS'Y PART LIST

REF NO. DESCRIPTION PART NO. Q'TY REMARK

C174,C175 CHIP CAPACITOR(20pF/ 50V,J,0805 TYPE,NPO) 413-DV330-315 2
C120 CHIP CAPACITOR(5pF/50V,J,0805 TYPE,NPO) 413-DV330-325 1
C133 CHIP CAPACITOR(0.068uF) 413-SMX701-755 1
IC105 IC(PCM1716E,28PIN,SOP) 417-DCM270X-327A 1
IC102 IC(CXD3068Q,QFP-80,SMD) 417-DCM280-587 1
IC101 IC(CXA-2581N,SSOP-30,SMD) 417-DCM280-588 1
IC108 IC(BA15218F/BA15218FE2,SOP-8) 417-QMX2-167 1
IC103 SERVO IC ASS'Y(CHECK SUM:A21D/23) 704-M510-5514 1
IC(SM8952AC25J,PLCC-44) 417-HDJ2450-693C 1

16
CONTROL P.C.B ASS'Y PART LIST

REF NO. DESCRIPTION PART NO. Q'TY REMARK

CONTROL PCB ASS'Y 704-M510-5510 1
BRACKET(L TYPE) 300-HDJ7000-472 2
W01,W02 4P CONNECTOR(P=2.54mm,SHD106-A03 TYPE) 404-QFX19-1621 2
D214,D227,D247,D206,D208 LED ( RED ) 410-CD6000-122 5
D207,D216 LED ( YELLOW ) 410-CD6000-123 2
D228,D221 LED ( GREEN ) 410-CD6000-124 2
D219,D220,D233,D234 LED(LTL1CHJGDNN,GREEN) 410-DJ5000-252 4
D235,D236,D209,D210 LED(LTL1CHJEDNN,RED) 410-DJ5000-253 4
D211,D212,D217,D218,D2
29,D230,D231,D232 LED ( LTL1CHJSDNN,YELLOW ) 410-HDJ2000-162 8
LED201,LED202 BACKLIGHT( BCS-002353BN ) 410-HDJ2400W-194 2
LCD201,LCD202 LCD(UTN-H406EV) 410-HDJP2450-273 2
J40 CARBON FILM RESISTOR(10K OHM,1/6W,J,T-26) 412-3113-068 1
RB204 THICK FILM RESISTOR NETWORKS(10K OHM,J,RA TYPE,5R6P) 412-HDJ200-263 1
R203,R213 CARBON FILM RESISTOR(100 OHM,1/4W,J,T-52) 412-PMSE1-279 2
CERAMIC CAPACITOR(0.1uF/50V,Z,TAPING,Y5V) 413-3113-035 3
CERAMIC CAPACITOR(1500pF/50V,K,TAPING,Y5P) 413-3113-041 2
C202,C217,C227 ELEC. CAPACITOR(100uF/10V,M,105℃,TAPING 5*11)(Cd,Pb,Hg,Cr) 413-3113-046 3
C226 ELEC. CAPACITOR(4.7uF/50V,M,105℃,TAPING 5*11)(Cd,Pb,Hg,Cr) 413-3113-050 1
L201 BEAD CORE(86-019-A TAPING) 415-HV3500K-090 1
VR201,VR202 SLIDE RESISTOR(10KB*2) 418-CD1000-052 2
CN01 SERIES STRIP PIN HEADER(90 DEGREES,2mm) 424-CDN88-032 1
X202 CRYSTAL 8MHZ 427-DV300-5017 1
X201 CRYSTAL(18.432MHZ) 427-DV330-042 1
D213,D214,D216,D227,D2
28,D247,D206,D207,D208, LED HOLDER(LED-7,H=7mm,WHITE) 504-CDN34A-042 11
D215,D221
SCREW(3*5 P=0.5) 602-B300-041 2
ADAPTOR PCB ASS'Y 704-DCD310-5477 1
BRACKET(L TYPE) 300-HDJ7000-472 1
JK201 DIN SOCKET SUPPORT BRACKET 300-HDJ7000-473 1
CN01A SERIES FEMALE PCB CONNECTORS 404-CDN88-017 1
LEAD WIRE(L=30mm,AWM1007 AWG26,BLACK) 406-MX3000-720 1
RB205 THICK FILM RESISTOR NETWORKS(10K OHM,1/8W J,RA TYPE,6R7P ) 412-KMD280-165 1
BEAD CORE(86-019-A TAPING) 415-HV3500K-090 1
IC203 IC(BA05T,3PIN) 417-CDN34A-314 1
JK201 8P DIN JACK(MDJ18-08) 420-HDJ7000-046A 1
JK202,JK203 HEADPHONE JACK(∮3.5,2K6A/-3537*01-030) 420-HDJ7100-063 2
HEAT SINK 425-P22-070 1
SCREW(3*8mm BTP) 602-2002-077 1
SCREW(3*5 P=0.5) 602-B300-041 1
C222,C223,C224,C225 CERAMIC CAPACITOR(1000PF/50V,K,TAPING,Y5P) 413-1430-071 4
C207,C208,C209,C210,C211,C212 CERAMIC CAPACITOR(220pF/50V,K,TAPING,Y5P) 413-3113-032 6
C201,C239 CERAMIC CAPACITOR(0.1uF/50V,Z,TAPING,Y5V) 413-3113-035 2
C240 ELEC. CAPACITOR(100uF/10V,M,105℃,TAPING 5*11)(Cd,Pb,Hg,Cr) 413-3113-046 1
ADAPTOR PCB(BARE) 405-310-1480 1

17
CONTROL P.C.B ASS'Y PART LIST

REF NO. DESCRIPTION PART NO. Q'TY REMARK

R204,R205,R206,R207,R208,R209 CARBON FILM RESISTOR(220 OHM,1/6W,J,T-26) 412-3113-058 6
L202,L203,L204,L205 BEAD CORE(86-019-A TAPING) 415-HV3500K-090 4
SW201,SW202,SW203,S
W204,SW205,SW206,SW2
07,SW208,SW209,SW210,
SW211,SW212,SW213,S
W214,SW215,SW216,SW2
17,SW218,SW219,SW220,
SW221,SW222,SW223,S TACT SW(H=5mm,TAPING) 403-DCM270X-101A 37
W224,SW225,SW226,SW2
27,SW228,SW229,SW230,
SW231,SW232,SW233,S
W234,SW235,SW236,SW2
37
C237 CERAMIC CAPACITOR(0.1uF/50V,Z,TAPING,Y5V) 413-3113-035 1
Q206,Q207,Q208 TRANSISTOR( 2SA933SR TAPING OR 2SA608G) 416-3113-008 3
CONTROL PCB ASS'Y SMT 704-M510-5510C 1
IC201 PLCC IC SOCKET(44PIN,SMD) 404-HDJ7100-788 1
CONTROL PCB(425*98mm) 405-310-1479 1
R214,R215,R216,R217,R222,R223 CHIP RESISTOR(270 OHM 1/8W 0805 J TP 150V ) 412-CDN88-014 6
J03,J22,J23,J31,J34,J102,
J103,J104,J106,J111,J112,
J113,J114,J13,J14,J15,J18
,J19,J20,J21,J25,J27,J28,J
29,J35,J36,J37,J42,J44,J5 CHIP RESISTOR(0 OHM,1/8W,1206,J,TP ,150V) 412-DJ3000-414 47
1,J54,J57,J59,J63,J67,J72,
J75,J76,J77,J78,J84,J85,J
87,J88,J95,J96,J99

R230,R232 CHIP RESISTOR(1K OHM,1/8W, 0805,J,TP 150V) 412-DV330-305 2

R260,R261,R262,R263,R2
64,R265,R266,R267,R202, CHIP RESISTOR(10K OHM,1/8W,0805,J,TP 150V) 412-DV330-306 11
R211,R212
R201 CHIP RESISTOR(1M OHM,1/8W, 0805,J,TP 150V) 412-DV330-308 1
R224,R247 CHIP RESISTOR( 2.2K OHM,1/8W,0805,J,TP 150V ) 412-DV330-313 2
R210 CHIP RESISTOR(3.3K OHM,1/8W, 0805,J,TP,150V) 412-DV330-317 1
R218,R219,R220,R221,R2
26,R227,R228,R248,R249,
R250,R251,R252,R253,R2 CHIP RESISTOR( 220 OHM,1/8W,0805,J,TP 150V ) 412-DV330-333 16
54,R255,R239
R229,R231 CHIP RESISTOR((470K OHM,1/8W, 0805,J,TP 150V) 412-QMX2-120 2
C233,C234 CHIP CAPACITOR(30pF/50V,J,0805 TYPE,NPO) 413-BJ2300E-628 2
C213,C214,C215,C216 CHIP CAPACITOR(0.01uF/50V,K,0805 TYPE,X7R) 413-DV330-312 4
C237,C203,C218,C228,C232 CHIP CAPACITOR(0.1uF/ 50V,Z,0805 TYPE,Y5V) 413-DV330-313 5
C204,C205 CHIP CAPACITOR(20pF/ 50V,J,0805 TYPE,NPO) 413-DV330-315 2
D237,D205,D222,D223,D2
24,D225,D226 SWITCHING DIODE(1SS355,UMD2,SMD,TAPING) 414-CD1000-075 7
Q205 TRANSISTOR(DTC124EKAT146/DTC124EKA) 416-CDN88-044 1
IC206 IC(74AHC595D/74AHC595DR,SOP-16) 417-HDJ9800-643 1
IC204,IC205 IC(BU9728AKV,SQFP-48) 417-P22-741 2
IC202 IC ASS'Y(CHECK SUM:670C/4) 704-P22NS-5474 1
IC(TMP86P202M/TMP86P202P/M,SOP20) 417-P22-733 1
IC201 CONTROL IC ASS'Y(CHECK SUM:EB82/17) 704-M510-5511 1
IC(SM8958AC25J,PLCC-44) 417-HDJ2450-693A 1

18
POWER P.C.B ASS'Y PART LIST

REF NO. DESCRIPTION PART NO. Q'TY REMARK

POWER PCB ASS'Y 704-P22NS-5465 1
CN01 5P SOCKET(P=3.75mm) 404-HV3363K-555 1
CN02 8P 2.5 CONNECTOR WIRE(L=300mm) 404-P22-1998 1
CN03 8P 2.5 CONNECTOR WIRE(L=370mm) 404-P22-1999 1
C01 ELEC. CAPACITOR(2200uF/16V,M, 105℃,BULK 13*21)(Cd,Pb,Hg,Cr) 413-3113-053 1
C04 ELEC. CAPACITOR(3300uF/16V,M, 105℃,BULK 13*26)(Cd,Pb,Hg,Cr) 413-HDJ200-230 1
D07,D08 DIODE(1N4001,1A/50V,TAPING 52mm) 414-DJ2500-110 2
D01,D02,D03,D04,D05,D06 RECTIFYING DIODE(1N5392,1.5A/100V,TAPING 52mm) 414-HT7016-031 6
IC01 IC(BA05T,3PIN) 417-CDN34A-314 1
IC03 IC(BA033T/FP 3.3V TO220FP 3PIN) 417-HV3500K-253 1
IC05 IC(AP-1084,TO220M) 417-P22-734 1
IC01,IC03,IC05 HEAT SINK 425-HDJ2650-040 3
MICA SHEET 501-P22-1824 1
CABLE TIE 504-S100-004 2
SCREW(3*8mm BTP) 602-2002-077 3
D05*2,D06*2 CERAMIC TUBE ( 4*2*11.5mm ) 605-KMD510P-034 4
TRANSISTOR SPACER(602S-VO) 606-P22-206 1
POWER PCB RT ASS'Y 704-P22NS-5465B 1
C14,C15,C16 CERAMIC CAPACITOR(0.01uF/50V,Z,TAPING,Z5V) 413-3113-028 3
C03,C06,C07,C11 CERAMIC CAPACITOR(0.1uF/50V,Z,TAPING,Y5V) 413-3113-035 4
C12 ELEC. CAPACITOR(2.2uF/50V,M,105℃,TAPING 5*11)(Cd,Pb,Hg,Cr) 413-3113-045 1
C05 ELEC. CAPACITOR(470uF/16V,M, 105℃,TAPING 8*12)(Cd,Pb,Hg,Cr) 413-HT8015-164 1
C02 ELEC. CAPACITOR(470uF/10V,M, 105℃,TAPING 8*12)(Cd,Pb,Hg,Cr) 413-HT8015-169 1
C08,C09,C10 ELEC. CAPACITOR(220uF/10V,M,105℃,TAPING 6.3*11)(Cd,Pb,Hg,Cr 413-KC220-119 3
IC02 IC(79L05A,TAPING,TO-92) 417-CDN44-392 1
R06 CARBON FILM RESISTOR(4.7K OHM,1/6W,J,T-26) 412-3113-055 1
R03 CARBON FILM RESISTOR(2.2K OHM,1/6W F T-26) 412-P22-960 1
R05 CARBON FILM RESISTOR(470 OHM,1/6W,F,T-26) 412-P22-961 1
POWER PCB(94V0,1.6t,140*100mm) 405-HDJP2450-1458A 1
IC04 IC(BD4745G/BD4745G-TR) 417-HDJ2000-503 1
FU01,FU02,FU03 CHIP FUSE(2.5A/63V) 422-120-064 3

19
BUFFER PCB ASS'Y PART LIST

REF NO. DESCRIPTION PART NO. Q'TY REMARK

BUFFER PCB ASS'Y 704-M510-5516 2
CN01 11P CONNECTOR(P=2.54mm,SHD106-A03 TYPE)(Pb,Cd) 404-EP1000-1331 1
CN02 12P CONNECTOR(P=2.54mm,SHD106-A03 TYPE) 404-HDJ7500-1336 1
CN03 2P SOCKET(CKM2501WV-2P 180°WHITE)(Cd,Pb,Hg,Cr) 404-KMD1500-608A 1
RB01 THICK FILM RESISTOR NETWORKS(10K OHM,1/8W J,RA TYPE,7R8P) 412-DJ1-420 1
C26,C28 ELEC. CAPACITOR(100uF/10V,M,105℃,TAPING 5*11)(Cd,Pb,Hg,Cr) 413-3113-046 2
L01 BEAD CORE(86-019-A TAPING) 415-HV3500K-090 1
X1 CRYSTAL( 16.9344MHz ) 427-KC710-019 1
BUFFER PCB 405-MCD2450-1239 1
R29 CHIP RESISTOR(270 OHM 1/8W 0805 J TP 150V ) 412-CDN88-014 1
R19,R26,R27 CHIP RESISTOR(10K OHM,1/8W,0805,J,TP 150V) 412-DV330-306 3
R01 CHIP RESISTOR(1M OHM,1/8W, 0805,J,TP 150V) 412-DV330-308 1
R02,R03 CHIP RESISTOR(4.7K OHM,1/8W,0805,J,TP 150V ) 412-DV330-320 2
R04,R07,R08,R09,R10,R11,R12,R13,R16 CHIP RESISTOR( 220 OHM,1/8W,0805,J,TP 150V ) 412-DV330-333 9
R30 CHIP RESISTOR (0 OHM,1/8W,0805,J,TP 150V) 412-HV3500K-367 1
R15 CHIP RESISTOR(300 OHM,1/8W,J,TP 0805,150V) 412-QFX19-555 1
C01,C02,C03,C04,C05,C0
6,C07,C08,C09,C10,C11,C
12,C13,C14,C18,C19,C20, CHIP CAPACITOR(0.1uF/ 50V,Z,0805 TYPE,Y5V) 413-DV330-313 25
C21,C22,C23,C25,C27,C2
9,C30,C31
C17,C16 CHIP CAPACITOR(15pF/ 50V,J,0805 TYPE,NPO) 413-DV330-314 2
U2 IC(K4S641632E-TC/K4S641632F/K4S641632H-TC75,TSOP-54) 417-CDN88-501 1
U5 IC(74HC04/74HC04DT,SOP-14) 417-DCM370E3-378 1
U1 IC(SCF5249LPV120,SMD) 417-MCDS4-736 1
U7 IC(BA18,SMD) 417-MCDS4-737 1
U8 BUFFER IC ASS'Y(CHECK SUM:73E4/1) 704-M510-5564 1
IC(XC9536XL-10VQ44C,SMD) 417-MCDS4-738 1
U3 IC ASS'Y(CHECK SUM:E9C1/22) 704-M510-5565 1
IC(M29W800B70N6.SMD) 417-MCDS4-735 1

20
OTHER P.C.B ASS'Y PART LIST

REF NO. DESCRIPTION PART NO. Q'TY REMARK

SENSOR PCB ASS'Y 704-DCD310-5478 2
D201,D202 IC(RPI-352) 417-CDN88-165 2
CN203 4P 2.54 SINGLE SERIES PIN LEADER(L=23mm,180°) 424-110-116 1
SENSOR PCB 405-MCD110-1464 1
R233,R234 CHIP RESISTOR(10K OHM,1/8W,0805,J,TP 150V) 412-DV330-306 2
R235,R237 CHIP RESISTOR(12K OHM,1/8W, 0805,J,TP,150V) 412-DV330-330 2
R236,R238 CHIP RESISTOR (470 OHM,1/8W, 0805,J,TP,150V) 412-VCDG3-395 2
Q201,Q202 TRANSISTOR(DTC124EKAT146/DTC124EKA) 416-CDN88-044 2

D-OUT PCB ASS'Y 704-DCD310-5482 2

CN301 2P SOCKET(S2B-PH-K,P=2mm,JST,90 DEGREE) 404-DJ3000-847 1
JK301 1P RCA JACK(RJ-1081-31-0341A) 420-HDJ2650-097A 1
D-OUT PCB RT ASS'Y 704-DCD310-5482B 1
C302 CERAMIC CAPACITOR(0.1uF/50V,Z,TAPING,Y5V) 413-3113-035 1
C303 ELEC. CAPACITOR(100uF/10V,M,105℃,TAPING 5*11)(Cd,Pb,Hg,Cr) 413-3113-046 1
C301 ELEC. CAPACTIOR(10uF/25V,M,105℃,TAPING 5*11)(Cd,Pb,Hg,Cr) 413-3113-052 1
Q301 TRANSISTOR(2SC1740R TAPING) 416-3113-007 1
D-OUT PCB(BARE,94V0,120*123*1.6t) 405-HDJ2650-649A 1
R302 CARBON FILM RESISTOR(100K OHM,1/6W,J,T-26) 412-3113-047 1
R304 CARBON FILM RESISTOR(4.7K OHM,1/6W,J,T-26) 412-3113-055 1
R303 CARBON FILM RESISTOR(220 OHM,1/6W,J,T-26) 412-3113-058 1
R305 CARBON FILM RESISTOR(6.8K OHM,1/6W,J,T-26) 412-3113-069 1
R306 CARBON FILM RESISTOR(6.2K OHM,1/6W,J,T-26) 412-HV3363K-349 1
R301 CARBON FILM RESISTOR(75 OHM,1/6W,J,T-26) 412-KCG220-197 1
L301 INDUCTOR(10uH TAPING 52mm) 415-MPG100-047 1

SW PCB ASS'Y 704-DCD310-5539 1

SW101*2 TACT SW(SKHHAM2520-HF,4PIN) 403-HV3420K-085 2
W08 3P-3P CONNECTOR WIRE ASS' Y(L=110mm,P=2-2.5mm) 404-HDJ7100-772 1
W08A 2P-3P CONNECTOR WIRE ASS' Y(L=270mm,P=2-2.5mm)(Pb,Cd) 404-HDJ7100-773 1
KNOB PCB 405-HDJ7100-387A 1
D105 LED ( LTL42UB5N,BLUE ) 410-NT2000-149 1
LED HOLDER(LED-7,H=7mm,WHITE) 504-CDN34A-042 1

AC JACK ASS'Y 704-MCD110-5706 1

AC JACK(SO-222-14RP) 404-DJ2-021 1
AC JACK PCB(394V0,37*34*1.6t) 405-DJ2-062A 1
FUSE JUMPER 406-3113-175 0
BEAD CORE(86-019-A TAPING) 415-HV3500K-090 2

21
 1 2 3 4
RB101
TO OP/CL SW. PCB 10KX7
W06 CN06
O/C SW 7V
3 3 R171
POWER LED R133 PUSW
2 2
PGND 1K FOK SW 10K
1 1 IC107 CLOK SW1
SW
3P 3P BA6218 XLAT CLSW
44
43
42
41
40
DATA OPSW
AOUT
BOUT
CURR

CND2

CND1

6
5
4
3
2
1
VCC

AIN

BIN

CN03 IC103 CN04

NC

OP/CL CLSW 12P

5

VCC
P1.4
P1.3
P1.2
P1.1
P1.0
P4.2

P0.0
P0.1
P0.2
P0.3
PGND LM- XRST R185 100
4 100 1
OPSW SENS 7 39 O/C SW SCOR R186
3 P1.5 P0.4 2
9
8
7
6
5
4
3
2
1

D TO LOADER2 LMA XRST 8 38 LMD+ D0 R187 100 D

P1.6 P0.5 3
LMB LM+ 9 37 LMD- D1 R188 100
1 P1.7 P0.6 D2 4
CN08 10 36 /2X R189 100
5P RST P0.7 5
RXD 11 35 D3 R190 100
C140 R169 1 RXD P89C61X2 EA/VP 6 TO BUFFER PCB
12 34 D4 R191 100
10/16 27 1/4W 2 P4.3 P4.1 7
TXD 13 33 D5 R192 100
TXD ALE 8
2P SCOR 14 32 D6 R193 100
INT0 PSEN 9
P SQSO 15 31 D7 D7 R194 100
INT1 P2.7 100 10
C139 SQCK 16 30 D6 ACKB R195
100P T0 P2.6 11
DEEMP 17 29 D5 ACKS R196 100
C137 T1 P2.5 12

XTAL2
XTAL1
220/10 ACKB
R182

VSS
P4.0
P2.0
P2.1
P2.2
P2.3
P2.4
ACKS

WR
RD
470K 5V C141 C176
C138 R183 Q102 0.1
FC- 0.1 470K A124ES

18
19
20
21
22
23
24
25
26
27
28
FC+ 0.1
R181
220K

TC+ R139 C179 5V

10K L104 NOTE: FOR CD2, JK102, CN09=NC, W09=3P.
TC- X102
R137 10uH 7V
R138C174
16
15
14
13
12
11
10

100/10 CN09 JK102

D0
D1
D2
D3
D4
9
8
7
6
5
4
3
2
1

47K
10K 20P 12M D DAK2 DAK2
C175 1 DST2 1

TO CONTROLLER
TO CD2 W09 DST2
2 2
GND

GND

TIN+
CIN2
CIN1
VREFI

TIN-
FIN+
CH3OF CH1OR

MUTE CH2OR

PREVCC PVCC

CH4IN VREFO
CH4OR CH1OF

CH3OR CH2OF

RESET

CH4BIAS FIN-

20P DDA2 DAK

IC106

3 3
DST
4
3P DDA2

DEEMP
BA5979S 5
DDA
6
CH4OF

REG-B
CH4IN

DAK +VCC
RECO
PVCC

W09 1 7
CIN3

SIN+
SIN-

SUB

DST 7V
2 8
DDA
NC 3 9
C142 DIN
DAK
17
18
19
20
21
22
23
24
25
26
27
28
29
30
31
32

C CN02 C
DST 0.1
DM+ CHASSIS
1 DDA
DM-
2
SD+
3 C145

C147
220P
TO MECH. 4 SD- C136 D103 220P

DATA
CLOK
R175 XLAT
SCOR

XRST
SENS
0.1 1SS132
FOK

5
PUSW C134 C133 C146
6

SQCK
SQSO
C135 0.1 .068
R178

220P
10K

6P 220/10 7V CN07

220
R180 R179 7V
R177 P 1
PGND

TO POWER PCB
470

R173
1.5K 2

220
220 R199 R198 R197 5V
220 5V 3
C131 220 220 3.3V
C128 D101 3.3V 4
DGND
0.1 1SS132 5
0.1
C118 L107 3.3V C181
/RST
6
0.1 +VCC
10/25 R107 7

R174

R176
-5V

21 C183
10uH

220

20 0.1
100K

220
R141 8
C130 A
100/10 D -5V 8P
560

28
27
26
25
24
23
22

19
18
17
16
15
R143 R108
220 2.2K

20
19
18
17
16
15
14
13
12
11
10
9
8
7
6
5
4
3
2
1
D

A124TS
NC
ZD101

MC

CS

AGND2R AGND2L
EXTL

LOUT
VCC1
MUTE
MD

ZERO
ML

MODE

RST

VCC2L
C160 C107

Q104
220/10 5.1B 10/25

COUT

CLOK
XUGF
MIRR

C2PO

XPCK

WFCK

SCLK

XRST
DVSS
IC105

SENS

XLAT
DATA

DVDD
WDCK

ATSK
SCOR

GFS

MUTE
C4M
PCM1716
D104
21 80

AGND1
DFCT EXCK

VCC2R
DGND
22 79

DATA

CLKO

ROUT
LRCK

EXTR
FOK SBSO

VDD
BCK

XTO
23 78 1SS132

XTI

NC
PWMI SCSY
R105 5V 24 77
120K LOCK SQCK R124
B 25 76 B
MDP SQSO 10
26 75
R103 C102 SSTP XOLT

10
11
12
13
14
C113

1
2
3
4
5
6
7
8
9
27 74
0.1

100/10 FSTO FSTO SOCK

15 28 73 X101
DVDD SOUT
Q101 29 72 33.8688M
R109 SFDR IC102 XTAO

10/25
C182
A933 30 71 C120
27K SRDR XTAI 5V
C115 31 CXD3068Q L102
70 5P L109 C161 C164
L103 TFDR DVSS
32 33uH
69 FB 10/25 0.1 C184
IC101 C108 TRDR XTSL
10uH 33 68 0.1
FFDR EMPH R126 R184
1000P CXA2581N 100/10 34 67
CN01 C101 R106 FRDR BCK 10
1 30 C114 35 66 220 5V
100/10 LD DCOFSET DVSS PCMD R123 L101 R142
VC 2 29 36 65
1 PD FRDC1 4.3K R130 TEST LRCK
5V C103 3 28 R129 37 64

8
2 EQIN RFDCO 0.1 TES1 DOUT 220 10uH 10 C143
E 0.1 4 27 47k 38 63 R125 C167
3 PCSM VCOUT VC MD2 R153 0.1 5 IC108B C165
D 5 2615K 39 62 220
4 GND RFC R132 FE ASYE R155
A 6 25 40 61 CN05 10K 7
5 A VFC SE DVDD 10/25 4.7K 15218
B 7 24R131 6
TO CD PICK UP

6 B BST 30k C129 DAK 1 R161

AVDD

AVDD
C 8 23 100K A 5V 10/25

ASYO
R134

VPCO
V16M
CLTV
RFDC

RFAC

VCTL
AVSS

AVSS
ADIO

IGEN

ASYI

BIAS
7 C RFG

FILO
DST 2 1K

PCO
0.1

FILI
F R101 9 22 150K C171

TO BUFFER PCB
CE
TE
8 D VCC DDA 3 180P
AGND 12K 10 21 C109 3.3V
9 E CE1 4 R170

4
LD R102 11 20 100/10 Q105
10 F CE R113 5 R157 C144
VR 12K 12 19 R135 R136 R114 R112 DGND C163 20K D1468
11 SW TBAL 6 C162 100K JK101

41
42
43
44
45
46
47
R12148
10K49
50
51
52
53
54
55
10K 56
57
C123 58
59
60
PD C106 13 18 47K 47K 15K 100K 15K D BCK R163

R119
12 DVCC TE 7 220/6.3 0.1 -5V

AUDIO OUT
FC+ R104 0.1 14 17 DB 0.1 R159 2.7K L
13 DVCOUT FE1 8 C169 100K C177
TC+ 470 C105 15 16 DD

R111
33K
14 RFAC FE 9 L105 .0015 1000P
TC- 0.1 R110 LRCK

220P
15 SW C111 C112 10

C121
FC- 150K C110 FSTO R

.047
0.01
16 0.1 220P FSTO 11 FB IC108A R160 C178
220P C170 3

R118
R115

1K
R154 100K 1000P
11P .0015 1 R164

R122
C104

100K
16P FFC 470K C168 10K 15218 C166
100/10 R156 2 2.7K CHASSIS

C125
Q106

R117
3.3K
C116
4.7K

820K
R120
0.1
A C117 10/25 C172 10/25 A

R116
R162 D1468

1M
0.1 R158 180P
C127 C122
C124 .0015 20K 1K
A 0.47/50 0.1
C132 3.3V
L108
.0033 C126 Title
100/10 10uH SERVO PCB
Size Number Revision
A3
405-MCD2450-1238 1
Date: 25-Jan-2005 Sheet of
File: G:\share\SB.DDB Drawn By: LEC
1 2 3 4
 1 2 3 4
R26
10K
C02 C01
0.1 0.1 R27
10K
J01
D BKPT D
/CS1 1 2
A17 R30 DSCLK
3 4
U3 TP20 TP18 0 5 6
142 A12

A16 1 48 R02 /RST DSI

140 A7
139 A8
138 A5
137 A6
136 A4

134 A3
133 A2

131 A1

A15 A16 R03 7 8

A15 2 47 TP21TP19 TP17 TP16TP15 4.7K DSO
144
143

141

135

132

130
129
128
127
126
125
124
123
122
121
120
119
118
117
116
115
114
113
112
111
110
109
A14 BYTE 9 10
A14 3 46 4.7K PST3
A13 VSS 11 12
A13 4 45 D31 PST2 PST1
A12 DQ15 13 14
A12 5 44 D23 PST0 DDATA3
A11 DQ7 15 16

DDATA0/GPIO0
CTS2_B/ADIN3/GPI31
DDATA2/GPIO2
DDATA1/GPIO1

DDATA3/GPIO4
RTS1_B/GPO30

RTS2_B/GPO31
TIN1/GPIO23

CS1/GPIO58

TOUT0/GPO33

TIN0/GP133
EBUIN4/ADIN1/GPI39

TDI/DSI
HI-Z
TEST1

A7
A8
A5
A6
A4

A3
A2

A1

SDATAI3/GPI41

TEST0
RXD1/GPI27
TXD1/GPO27

TXD2/GPO28
PAD-VDD

CORE-VDD

PAD-GND

CORE-GND

CTS1_B/GPI30

TDSO
A12

RXD2/GPI28/ADIN2
A11 6 43 D30 DDATA2 DDATA1
A10 DQ14 17 18
A10 7 42 D22 DDATA0 RB01
A9 DQ6 19 20
A9 8 41 D29 TP1 10KX7
A8 DQ13 21 22
A20 9 40 D21 1 108 PSTCLK
A19 DQ5 SCL/QSPI_CLK PST0/GPIO59 23 24
10 39 D28 2 107 C22 TA 3.3V
NC DQ12 CS0 PST2/GPIO61 25 26

C15
47P
11 38 D20 C11 A21 3 106
WE DQ4 A21 PAD-VDD
12 37 A11 4 105 HEADER 13X2
RESET VDD A11 PST1/GPIO60 L01
13 36 D27 A10 5 104 0.1
NC DQ11 0.1 A10 VNPSTCLK/GPO63 FB C30
14 35 D19 A9 6 103 0.1
WP DQ3 A9 PST3/GPIO62
15 34 D26 A18 7 102
RY/BY DQ10 A18 PAD-GND U5
A19 16 33 D18 A17 8 101
A18 DQ2 A17 TCK

14
13
12
11
10
A18 17 32 D25 9 100 74HC04

9
8
A17 DQ9 BCLK/GPIO10 CORE-GND
A8 18 31 D17 10 99
A7 DQ1 TP2 SCLK_OUT/GPIO15 TMS/BKPT
A7 19 30 D24 11 98
A6 DQ8 BCLKE RW_B R/W

6A
6Y
5A
5Y
4A
GND 4Y
1A VDD
A6 20 29 D16 12 97 C09
A5 DQ0 TP3 SDA/QSPI_DIN CORE-VDD
A5 21 28 D24 13 96 0.1
A4 OE DATA24 TRST/DSCLK
A4 22 27 A22 14 95

1Y
2A
2Y
3A
3Y
A3 VSS A22 XTRIM/GPO38
A3 23 26 15 94
C A2 CE SDUDQM MCLK2/GPO42 TP14 C
A2 24 25 16 93
A1 A0 EF/GPIO19 MCLK1/GPO39 TP13 R01
D25 17 92
DATA25 IDE-IORDY/GPIO16 1M

1
2
3
4
5
47 6
7
A1 AM29LV160DB D26 18 U1 91 16M
DATA26 IDE-DIOR/GPIO13 X1

R15
D27 19 MCF5249LPV120 90
DATA27 CRIN
20 89
PAD-GND IDE-DIOW/GPIO14 C10
D28 21 88 C17 C16
DATA28 PLLCOREVDD
D29 22 87 0.1 15P 15P
C14 DATA29 PLLCOREGND
U2 23 86 C08
TP4 SDATA3/GPIO56 PLLPADVDD
0.1 1 54 D30 24 85 0.1 CN01
VCC VSS C03 DATA30 PLLPADGND
D16 2 53 D31 25 84
C18 DQ0 DQ15 0.1 BUFFNB1/GPIO57 PLLGRDGND C07 DAK 1
3 52 D31 26 83
0.1 VCCQ VSSQ DATA31 PLLGRDVDD DST 2
D17 4 51 D30 27 82 0.1
DQ1 DQ14 CORE-VDD EBUIN1/GPI36 DDA 3
D18 5 50 D29 C12 A13 28 81 R04
DQ2 DQ13 A13 SDATAI1 5V 4 TO SERVO PCB
6 49 29 80 220
VSSQ VCCQ CORE-GND TA/GPIO20 3.3V 5
D19 7 48 D28 A23 30 79 DGND
DQ3 DQ12 0.1 A23 SCLK4/GPIO50 6
D20 8 47 D27 A14 31 78 R10 BCK
C19 DQ4 DQ11 A14 SCLK1 7
9 46 A15 32 77 220 DB

TOUT1/ADOUT/GPO35
VCCQ VSSQ A15 SDATAI4/GPI42 TP12 8
C04

EBUIN3/ADIN0/GPI38
0.1 D21 10 45 D26 0.1 A16 33 76 DD

SDATA1_BS1/GPIO9

QSPI_DOUT/GPIO26
DQ5 DQ10 A16 LRCK4 TP11 9
D22 11 44 D25 34 75 R12 LRCK

QSPI_CS0/GPIO29

QSPI_CS2/GPIO21
C13

SDATAO2/GPO41
EBUOUT1/GPO36
DQ6 DQ9 PAD-VDD LRCK1 10
12 43 A19 35 74 220 FSTO

LRCK2/GPIO44

SCLK2/GPIO48
VSSQ VCCQ A19 SDATAO1/GPIO25 11

EBUIN2/GPI37
CFLG/GPIO18
D23 13 42 D24 A20 36 73 11P 3.3V

SDA2/GPO55
DQ7 DQ8 A20 TEST3 C23

SCL2/GPIO3
0.1

CORE-GND

CORE-VDD
C20 14 41 0.1

PAD-VDD

PAD-GND
VCC VSS

SDLDQM
0.1 15 40 SCLK4

DATA21
DATA19

DATA20
DATA22
DATA18
DATA23
DATA17

DATA16
DQML NC

SDRAS
SDCAS
SDCS1
TEST2

GPIO5

GPIO6
SDWE
16 39
/WE DQMU

RSTI

44
43
42
41
40
39
38
37
36
35
34
17 38

OE
/CAS CLK U8
B 18 37 B
/RAS CKE
19 36 CN02
/CS NC

42
41
40
39
38
37
GCK2
GCK1

VCC5V
GTS1

GTS2
A22 20 35 A20 R16 ACKS
A13 A11 12

D21
D19

D20
D22
D18
D23
D17

D16
37
38
39
40
41
42
43
44
45
46
47
48
49
50
51
52
53
54
55
56
57
58
59
60
61
62
63
64
65
66
67
68
69
70
71
72
A21 21 34 A18 TP10 220 ACKB 1 33
A12 A9 11 GCK3 GSR
A19 22 33 A17 TP8 D7 D0 2 32 D31
A10 A8 10 2 32

TO SERVO PCB
A16 23 32 A9 D6 D1 3 31 D30
A0 A7 GPO55 9 3 31
A15 24 31 A10 D5 4 30 D29
A1 A6 8 GND 30
A14 25 30 A11 D4 D2 5 29 D28
A2 A5 7 5 29
C21 A13 26 29 A12 D3 D3 6 XC9536-15-VQ44 28 D27
A3 A4 C06 6 6 28
27 28 C05 D2 D4 7 27 D26
VCC VSS 5 7 27
0.1 D1 D5 8 26 C31 3.3V
0.1 0.1 4 8 VCC3.3V
K4S641632D D0 9 25
R11 3 TD1 GND
220 SCOR 10 24 0.1
/OE 2 TMS TD0
XRST 11 23 D25
1 TCK 23

VCC5V
R07
DST

GND
220 R29 12P

12
13
14

16

18
19
20
21
22
R09 270
DAK
220 U7 D6 D24
R08 BA18C0FP D7
DDA

12
13
14
15
16
17
18
19
20
21
22
DOUT PCB 405-HDJ2650-649A 220 5V CN03 3.3V C29
3.3V GPO55
L301 1 O I R/W
C28 0.1
2 /CS1

G
10uH R13 100/10
R304 Q301 220 2P C27 C26 C25
0.1 CN04 /OE
CN301 4.7K C1740 0.1 100/10
R306 R19

6
5
4
3
2
1
5V C301 JK301 JTAG
1 6.2K R301 3.3V
A DOUT 10K A
2
75 3
2P R305 R30310/25 1
C303 R303
C302 6.8K 220 Title
100/10 100K
0.1 BUFFER PCB/DOUT PCB

G
CHASSIS Size Number 405-MCD2450-1239 Revision
405-HDJ2650-649A 1
B
Date: 18-Jan-2005 Sheet of
File: G:\share\SCHS\sch.DDB Drawn By: LEC
1 2 3 4
 1 2 3 4
D D
POWER PCB
CN02
8P
7V
1
PGND
2
5V
3
IC05 3.3V
R03 4 TO CH1 SERVO PCB
DGND
2.2K,1% 5

OUT
ADJ
/RST
6

IN
+VCC
D01 D02 C01 R05 7
-5V
1N5392 1N5392 2200/16 8

3
2
1
AMC7588-ADJT 470,1%
C03 C02 CN03
0.1 470/10 7V
C14 1
C IC03 PGND C
0.01 BA33 2
5V
3
3.3V
4
FU01 DGND TO CH2 SERVO PCB

COM
CN01 I O 5
2.5A C11 C10 /RST
D03 D04 6
220/6.3 +VCC
5 0.1 7
1N5392 1N5392 -5V
4 8
FU02 IC01
POWER SW.

3 C04
2.5A BA05 8P
2 3300/16
1
.0047/250

COM
FU03 I O
IC04

0.01
C06

C15
5P,P=3.96 2.5A
C08 1 5 R06
0.1 NCVCC
220/6.3 2 10K

1N5392
1N5392
SUB

D05

D06
3 4
GNDVO
C16 C12
0.01 CHASSIS BD4745G 2.2/50
FUSE C05
240V/1A D07 D08
B DC : 9V / 2A 470/16 B

1
1N4001 1N4001
L N DC : 7V / 1A C07 C09
0.1 220/6.3

G
2 3
I O
IC02
79L05
AC IN
Title
A A
POWER PCB
Size Number Revision
405-2450-1458A 2
A3
Date: 10-Mar-2005 Sheet of
File: G:\share\PCB.DDB Drawn By: LEC
1 2 3 4
 1 2 3 4
5V IC203 405-1480
5V BA05
RB203 5V
R203 C214 PITCH1 10KX6 C201
0.01 C216 O I C235
BLUE Y.G C233 C234 VR201 C236
10,1/4W 30P 30P 0.01

G
100,1/4W 10KB 0.1
C213 100/10
X202 IC202 C215
0.01
LEDPLATE

0.01 R204
LED201

TMP86P202
LED201A

0.1
LCD201 220
1 20 ACK1
8M VSS P37AI5
2 19
D XIN P36/AI4 R205 JK201 D
3 18 STB1
XOUT P35/AI3 PITCH2
C232 4 17 220 DAK2
0.1 TEST P34/AI2 R206 1
5 16W1A DATA1 DST2
VDD P33 2
PC1B6 15W1B 220 DAK
S30
C1
C2
C3
C4

P00 P32 3
S1

7 14W2A VR202 ACK2 R207 DST

P01 P31 4
8 13W2B 10KB 220 DDA2 TO MAIN UNIT
/RST P30 R208 5
9 12 STB2 DDA
1COM0
1COM1
1COM2
1COM3

P20 P12 6
1S2410
1S2311
1S2212
1S2113
1S2014
1S1915
1S1816
1S1717
1S1618
1S1519
1S1420
1S1321
1S1222
1S1123
1S1024
1S9 25
1S8 26
1S7 27
1S6 28
1S5 29
1S4 30
1S3 31
1S2 32
1S1 33
1S0 34
1
2
3
4
1S29 5
1S28 6
1S27 7
1S26 8
1S25 9

10 11 220 +VCC
P10 P11 R209 7
DATA2 NC
8
RB204 220 C211C210 C209 C208 9
10KX5 C212 C207
DIN
271S10
281S11
291S12
301S13
311S14
321S15
331S16
341S17
351S18
361S19

220P 220P
251S8
261S9

ACK 220P 220P 220P 220P

IC204 STB
CHASSIS
DAT PC1A
S10
S11
S12
S13
S14
S15
S16
S17
S18
S19
S8
S9

L202
1S7 24 371S20 /RST FB
S7 S20
1S6 23 381S21 PC1A JK202
S6 S21 L
1S5 22 391S22 5V KR1 L203
S5 S22 PC1
1S4 21 401S23 405-MCD110-1464 PC1B
S4 S23 G
1S3 20 411S24 D201 D202 FB
S3 S24 SW236
1S2 19 421S25 SW201 SW208 SW215 SW222 SW229
S2 S25 C222 C224
1S1 18 BU9728AKV 431S26 R234 %2 STOP 2 STOP 1 CUE 2
S1 S26 R233 RELOOP 2 OUT 1 1000P 1000P
1S0 17 441S27
S0 S27 10K 10K
16 451S28 KR2 L204
/RST S28 PRI-352 PRI-352 CHASSIS
1COM3 15 461S29 R236 R238 FB
COM3 S29 SW237
C 1COM2 14 47 W1A PC2A
COM2 S30 Q202 470 470 SW202
SW216 L JK203 C
1COM1 13 48 SW209 SW223 SW230 IN 2 L205
COM1 S31 PITCH 2 PC2
OUT 2 PITCH+ 1 PLAY 1 IN 1 PC2B
COM0

Q201
OSC2
OSC1

G
VDD
SCK

VSS
C/D

SD

V3
V2
V1
CS

C124ES FB
R237 KR3
R235 C124ES 12K C223 C225
1COM0
R229 12K SW203 1000P 1000P
C218

CHASSIS
12
11
10
9
8
7
6
5
4
3
2
1

470K W1B 5V SW210 SW217 SW224 SW231

R230 PITCH+ 2
RELAY RELOOP 1
FB 2 CUE 1
1K D203 D204 /RST 5V
KR4
/RST

/CS1

SCK
C/D

SD

0.1 C217 R240 R210 C226

5V R239
100/10 10K 10K SW204 3.3K 4.7/50
SW211 SW218 SW225 SW232 Q206
PRI-352 R242 PRI-352 SGL/CTN 2 R211
R244 BSKIP 2 PITCH 1 %1 A933
470 PITCH- 1
5V W2A 470 10K
Q204
KR5 RST
R213 Q203 Q205
BLUE Y.G SW205 SW212 R212 C124ES D205
10,1/4W C124ES SW219 SW226 SW233 10K
100,1/4W R243 1SS132
LCD202 R241 C124ES 12K TIME 2 REPEAT 2 FF 1 SGL/CTN 1
TIME 1
12K

LEDPLATE
LED202A
W2B KR6
LED202
C237
RB201 5V 0.1
10KX8 SW206 SW220 SW227 SW234 R218 D209
S30

SW213
C1
C2
C3
C4
S1

PITCH- 2 FB 1 FSKIP 1 IC206 560

FF 2 +10 1 D210
9 8 R219
B DSO GND B
KR7 /RST 10 7CUE2
2COM0
2COM1
2COM2
2COM3

MR Q7 560
2S2410
2S2311
2S2212
2S2113
2S2014
2S1915
2S1816
2S1717
2S1618
2S1519
2S1420
2S1321
2S1222
2S1123
2S1024
2S9 25
2S8 26
2S7 27
2S6 28
2S5 29
2S4 30
2S3 31
2S2 32
2S1 33
2S0 34
1
2
3
4
2S29 5
2S28 6
2S27 7
2S26 8
2S25 9

SHCP 11 6 IN2 R220 D211

SHCP Q6
STCP 12 5OUT2 560
SW207 SW214 SW221 SW228 SW235 STCP Q5 D212
/OE 13 4PLAY2 R221
+10 2 OE Q4
FSKIP 2 PLAY 2 BSKIP 1 REPEAT 1 DS 14 3 IN1 560
DS Q3 R226 D217
15 2
272S10
282S11
292S12
302S13
312S14
322S15
332S16
342S17
352S18
362S19

Q0 Q2
252S8
262S9

42 ACK2
16 1

41 STB1

43 STB2

3 ACK

5 DAT
2 /CS1
1 C/D\
560

4 STB
D222 VCC Q1

40ACK1
D224 D225 D226 R227 D218

6 PC1A
D223 D237
IC205 KS1 1SS132 1SS132 1SS132 1SS132 1SS132 1SS132 74595 560

44
KS2 R228 D219
S10
S11
S12
S13
S14
S15
S16
S17
S18
S19
S8
S9

KS3 560
2S7 24 372S20 KS4 R239 D220
S7 S20

P0.3
P0.2
P0.1
P0.0

P4.2
P1.0
P1.1
P1.2
P1.3
P1.4
VCC
2S6 23 382S21 KS5 560
S6 S21 D229
2S5 22 392S22 39
PC2A 7 /CS2 KS6 R248
S5 S22 P0.4 P1.5
2S4 21 402S23 PC2B38 8 KS2
S4 S23 P0.5 P1.6 560 D230
2S3 20 412S24 SHCP 37 9 KS1 R249
S3 S24 P0.6 P1.7 R215 R217
2S2 19 BU9728AKV 422S25 STCP 36 10RST R214 R216 R222 R223 560
S2 S25 P0.7 RST 270 270 D231
2S1 18 432S26 35 11SD 270 270 270 270 OUT1 R250
S1 S26 EA/VP RXD
2S0 17 442S27 /OE 34 IC201 12KS6 560
S0 S27 P4.1 SM8958A P4.3 R251 D232
16 452S28 R202 33 13SCK LEDC1
/RST S28 ALE TXD Q207 D206 D207 D247 D213 D214 D215
2COM3 15 462S29 32 14DATA1 560 R252
COM3 S29 PSEN INT0 A933 D233
2COM2 14 47 DS 31 15DATA2 R224 PLAY1
COM2 S30 P2.7 INT1
2COM1 13 48 KS5 10K 30 16LEDC2 2.2K 560 R253
COM1 S31 P2.6 T0 D234
KS4 29 17LEDC1

COM0

OSC2
OSC1
P2.5 T1

VDD

XTAL1
XTAL2
SCK
D208 D221 D227 D216 D228

VSS
CUE1

C/D

SD
560 R254

V3
V2
V1
CS
TP D235

VSS
P2.4
P2.3
P2.2
P2.1
P2.0
P4.0
LEDC2

WR
RD
2COM0 560
R231 KS3 KR2 R255 D236

C228
A R247 A

12
11
10
9
8
7
6
5
4
3
2
1
470K KR7 KR1 2.2K 560

28
27
26
25
24
23
22
21
20
19
18
R232 KR6 Q208
1K KR5 R201 KR3 A933
KR4 1M Title

/RST
C203

/CS2

SCK
5V

C/D

SD
0.1 C227 X201 CONTROL PCB
5V
100/10 5V 0.1
FB C202 C205 Size Number 405-310-1479/1480 Revision
L201 100/10 18.432M 405-MCD110-1464 1.2
20P B
C204 Date: 10-Mar-2005 Sheet of
20P File: G:\share\PCB.DDB Drawn By: LEC
1 2 3 4
Printed Circuit Board

26
Printed Circuit Board

AC JACK PCB

27
Printed Circuit Board

28
Printed Circuit Board

29
Printed Circuit Board

30
31
Printed Circuit Board

32
IC Block Diagram

417-HDJ2000-503 IC(BD4745G/BD4745G-TR)

VCC

VOUT

Vref

GND

417-DCM370E3-378 IC(74HC04/74HC04DT,SOP-14)

33
IC Block Diagram

417-KC720-049
BA6218

MOTOR
Control
logic

1 2 3 4 5 6 7 8 9

417-DCM280-588

AC_SUM
V CC

EQ_IN
CXA-2581N

RFG

RFC
VFC
BST
4 3 23 24 26 25

AC AC
EQ
SUM VCA
15 RFAC
EQ_ON/OFF

RW/ROM
30 DC_OFST

29 RFDCI
DVCC
VC RW/ROM 28 RFDCO
VC
A 6
17 FEI
B 7 DVCC
C 8 16 FE

D 9 VOFST DVC
RW/ROM
VC
19 TE_BAL
RW/ROM

VOFST RW/ROM
VC
F 10 gm DVCC

18 TE
E 11 gm
VC
VOFST RW/ROM

B
DVC 21 CEI
C DVCC
A
22 5 27 14 20 CE
D DVC
VC
RW/ROM
APC-OFF (Hi-Z) DVC
SW 12 RW/ROM VC VOFST
(H/L)
VCC
PD 2 APC VC 13 DVCC
LD 1 VC DVC
VCC

34
VCC

GND

VC

DVC
IC Block Diagram

417-HDJ2000-503 IC(BD4745G/BD4745G-TR)

VCC

VOUT

Vref

GND

417-DCM370E3-378 IC(74HC04/74HC04DT,SOP-14)

35
IC Block Diagram

417-DCM270X-327A

417-CDN88-501

I/O Control
LWE
K4S641632E
Data Input Register
LDQM
Bank Select

1M x 16
Refresh Counter

Output Buffer
Row Decoder

Sense AMP
Row Buffer

1M x 16
DQi
Address Register

1M x 16
CLK
1M x 16

ADD

Column Decoder
LRAS

LCBR

Col. Buffer

Latency & Burst Length

LCKE
Programming Register
LRAS LCBR LWE LCAS LWCBR LDQM

Timing Register

CLK CKE CS RAS CAS WE L(U)DQM

417-CDN34A-314
BA05T

V cc Reference
1 volta ge
-

- OUT
-

3
+
GND
2

36
IC Block Diagram

417-DCM280-587

WDCK
WFCK

PCMD
EMPH

MUTE
VPCO

C2PO
XUGF
XTAO

V16M

LRCK
XTSL

VCTL
XTAI

BCK
GFS
CXD3068Q
71 72 69 59 60 58 11 13 68 10 17 14 65 66 67 3
37 TES1
36 TEST
FSTO 27 Clock Error
2 XRST
C4M 16 Generator Corrector
EFM D/A
RFAC 50 demodurator Interface
ASYI 49
Asymmetry
ASYO 48
Corrector
ASYE 62 32K
Digital 63 MD2
BIAS 57 RAM
OUT 64 DOUT

XPCK 12
Sub Code
FILO 53 Processor
Digital
FILI 54
PLL
PCO 55
CLTV 52
MDP 25
Digital
LOCK 24
CLV
PWMI 23

SENS 7
DATA 4
XLAT 5
CLOK 6
SCOR 15 CPU
SBSO 79 Interface

EXCK 80 Servo
SCSY 78 Auto
Sequencer
SQSO 76
SQCK 77
Signal processor block

Servo block
73 SOUT
74 SOCK
75 XOLT
SERVO 8 SCLK
Interface
19 COUT
26 SSTP
9 ATSK
20 MIRR
MIRR
DFCT 21 DFCT
RFDC 43 FOK 22 FOK
CE 42
TE 41 SERVO DSP PWM GENERATOR
33 FFDR
OPAmp A/D FOCUS PWM
SE 40 FOCUS SERVO
Analog SW Converter GENERATOR 34 FRDR
FE 39
TRACKING TRACKING PWM 31 TFDR
VC 38 SERVO GENERATOR 32 TRDR
IGEN 46
SLED PWM 29 SFDR
SLED SERVO
GENERATOR
30 SRDR

44
ADIO

37
 IC Block Diagram

417-HDJ2450-693C
SM8951/SM8952A

Stack Decoder & 128/256

Timer 2 Timer 1 Timer 0 Pointer Register bytes RAM

Buffer
WDT

RES Reset to pertinent blocks

DPTR
Circuit Acc

Vdd to whole chip PC

Power Incrementer
Vss Circuit
Buffer2 Buffer1

to pertinent blocks Program

Interrupt ALU Counter
Circuit

Register
PSW
XTAL2
XTAL1 to whole system
#EA
Timing
ALE
Generator
#PSEN

4/8 K
Instruction bytes
Register Flash
Port 0 Port 1 Port 2 Port 3 Memory
Latch Latch Latch Latch

Port 0 Port 1 Port 2 Port 3

Driver & Mux Driver & Mux Driver & Mux Driver & Mux

8 8 8 8

38
IC Block Diagram

417-P22-741
BU9728AKV-E2
VDD

LCD Driver V1
Bias Circuit V2
RESET
V3
VSS

SEG0
SD
SCK Serial Address LCD SEG1
C/D Interface Counter Segment
CS Driver
Display Data RAM 32bits
(DD RAM)
SEG31

Command / Data
Register
COM0
LCD
Common COM1
Timing Driver
Common COM2
Command Generator 4bits
Counter
Decoder COM3
OSC1

OSC2

417-CDN24-341
BA07T

V cc
1 Reference volta ge -

- OUT
-

3
+
GND
2

39
IC Block Diagram

417-MCDS4-738 IC(XC9536XL-10VQ44C,SMD)

417-MCDS4-737 IC(BA18BCOFP-E2,SMD)

BA18BCO

(1) (2) (3)

40
IC Block Diagram

417-MCDS4-735 IC(M29W800B70N6.SMD)

417-P22-733
TMP86P202M

41
IC Block Diagram

417-MCDS4-736 IC(SCF5249LPV120.SMD)

417-DCM280-596
VA5979S

32 31 30 29 28 27 26 25 24 23 22 21 20 19 18 17

100 10k
PreVCC POWVCC 50k
D D D D
F R 50k
10k R MUTE
＋
−

＋−
INTER-
19k
FACE

F LEVEL
10k
SHIFT
POWVCC
50k
THERMAL
Vref
F 50k SHUTDOWN

INTER-
FACE REGULATOR
R F T. S. D
F R MONITOR

INTER-
FACE R
F R POWVCC D D D D

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16

T. S. D；サーマルシャットダウン
D；ドライブバッファ
抵抗値の単位は〔Ω〕

42
Trouble Shooting

SYMPTOM POSSIBLE CAUSE CORRECTION ACTION

Device dose not react when Connection to main disrupted Check AC plug and AC connection
switching on
Player does not start operation CD is badly positioned or dirty Reposition CD with label atop or clean
with a dry and soft cloth
No sound Check the mixer and amplifier Possibly exchange connections
connections inappropriate
Does not read properly The device is exposed to vibrations Place the device on a more stable stand,
rack etc.
Does not read the program The player is in normal playback mode Press the Play-Pause button and
re-program
Pop noise Mixer and amplifier connections Check cable and jack quantity
inappropriate

43