Product Data: Single Packaged Convertible Gas/Electric 14 SEER 2-5 Ton
Product Data: Single Packaged Convertible Gas/Electric 14 SEER 2-5 Ton
Product Data: Single Packaged Convertible Gas/Electric 14 SEER 2-5 Ton
WARNING
HAZARDOUS GASES!
Exposure to fuel substances or by-products of incomplete fuel combustion is believed by
the state of California to cause cancer, birth defects, or other reproductive harm.
This warning complies with state of California law, Proposition 65.
WARNING
HAZARDOUS VOLTAGE!
Failure to follow this Warning could result in property damage, severe personal injury, or
death.
Disconnect all electric power, including remote disconnects before servicing. Follow
proper lockout/tagout procedures to ensure the power cannot be inadvertently energized.
WARNING
SAFETY AND ELECTRICAL HAZARD!
Failure to follow this Warning could result in property damage, severe personal injury, or
death.
These servicing instructions are for use by qualified personnel only. To reduce the risk of
electrical shock, do not perform any servicing other than that contained in these
operating instructions unless you are qualified to do so.
CAUTION
GROUNDING REQUIRED!
Failure to inspect or use proper service tools may result in equipment damage or
personal injury.
Reconnect all grounding devices. All parts of this product that are capable of conducting
electrical current are grounded. If grounding wires, screws, straps, clips, nuts, or washers
used to complete a path to ground are removed for service, they must be returned to their
original position and properly fastened.
WARNING
UNIT CONTAINS R-410A REFRIGERANT!
Failure to use proper service tools may result in equipment damage or personal injury.
R-410A operating pressure exceeds the limit of R-22. Proper service equipment is
required. Service using only R-410A Refrigerant and approved POE compressor oil.
WARNING
SAFETY HAZARD!
Operating the unit without the access panels properly installed may result in severe
personal injury or death.
Do not operate the unit without the evaporator fan access panel or evaporator coil access
panel in place.
WARNING
WARNING!
This product can expose you to chemicals including lead, which are known to the State of
California to cause cancer and birth defects or other reproductive harm. For more
information go to www.P65Warnings.ca.gov.
I m p o r t a n t : Wear appropriate gloves, arm sleeve protectors and eye protection when servicing or
maintaining this equipment.
I m p o r t a n t : Air filters and media wheels or plates shall meet the test requirements in UL 900.
22-1901-1J-EN 3
Table of Contents
Single Packaged Convertible Gas/Electric Systems . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5
Optional Equipment Listing. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6
Product Specifications . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8
Indoor Fan Performance . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 13
Field Wiring Diagram . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 20
Wiring — 4YCC4 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 21
Full Perimeter Roof Mounting Curb . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 27
Optional Equipment — Economizer. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 29
Optional Equipment — Outside Air Damper . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 30
Optional Equipment — Filter Rack . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 31
Outline Drawings . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 32
4 22-1901-1J-EN
Single Packaged Convertible
Gas/Electric Systems
Trane offers a complete family of packaged gas/electric heating and cooling systems, designed to
provide the unbeatable combination of energy efficiency and lower operating costs. In warm
weather, the package gas/electric system functions as an all-electric, high efficiency air
conditioner. In cold weather, it operates as a natural gas or propane gas furnace, offering the
best of both energy worlds.
Because cooling and heating functions are all contained in a single cabinet, a single
packaged convertible gas/electric system is easy to install and service.
It can be flush mounted beside your home at ground level or placed on the roof for horizontal or
downflow installation. When connected to an optional American Standard thermostat control,
and air distribution ducts, you have a highly efficient, total home comfort system.
All major components on these products, including the compressor, have been designed and
manufactured for maximum service. Every compressor is designed and manufactured to
exacting specifications. Each design is life tested in extreme environments to ensure reliable and
long lasting operation in normal applications. Each compressor has internal motor protection for
added reliability.
Our single packaged cooling/heating units offer cooling/heating efficiencies that are unmatched
in the industry and provide you with a product far superior in performance than the competition.
22-1901-1J-EN 5
Optional Equipment Listing
* = T, W, or Y
Hinged Filter Access Door (4*CC4024–036) (4*CY4024–4036) BAYCCDOR1A [ ]
Hinged Filter Access Door (4*CC4042–060) (4*CY4042–4060) BAYCCDOR2A [ ]
Roof Curb Full Perimeter (4*CC024–036A) (4*CY4024–4036) BAYCURB050A [ ]
Roof Curb Full Perimeter (4*CC042–060A) (4*CY4042–4060) BAYCURB051A [ ]
Roof Curb Utility Extension Kit (BAYCURB050A) BAYUTIL101B [ ]
Roof Curb Utility Extension Kit (BAYCURB051A) BAYUTIL101B [ ]
0–25% Manual Fresh Air Damper (4*CC4024–36A) (4*CY4024–4036)(a) BAYOSAH001A [ ]
0–25% Manual Fresh Air Damper (4*CC4042–60A) (4*CY4042–4060)(a) BAYOSAH002A [ ]
Motorized Fresh Air Damper (4*CC4024–036A) (4*CY4024–4036)(a) BAYDMPR101A [ ]
Motorized Fresh Air Damper (4*CC4042–060A) (4*CY4042–4060)(a) BAYDMPR102A [ ]
16” Round Duct Adapter (2 per box) (4*CC4024–036A) (4*CY4024–4036)(b) BAYSQRD001A [ ]
18” Round Duct Adapter (2 per box) (4*CC4024–060A) (4*CY4024–4036)(b) BAYSQRD002A [ ]
0–100% Mod Economizer w/Baro. Relief (4*CC4024–036A) (4*CY4024–4036)(a)(c) (d) BAYECON101B [ ]
0–100% Mod Economizer w/Baro. Relief (4*CC4042–060A) (4*CY4042–4060)(a)(d) BAYECON102B [ ]
0–100% Horizontal Economizer (4*CC4024–36A) (4*CY4024–4036)(a) BAYECON200B [ ]
0–100% Horizontal Economizer (4*CC4042–60A) (4*CY4042–4060)(a) BAYECON201B [ ]
Enthalpy Control for Economizer (ALL-BAYECON) BAYEENTH001A [ ]
Remote Potentiometer (ALL-BAYECON) BAYSTAT023 [ ]
1”—2” Filter Frame (4*CC4024–036A) (4*CY4024–4036) (18 x 25 filter not included) BAYFLTR101C [ ]
1”—2” Filter Frame (4*CC4042–060A) (4*CY4042–4060) (two 18 x 20 filters not included) BAYFLTR201C [ ]
Head Pressure Control (Low Ambient Cool) (208/240v) Kit BAYLOAM105A [ ]
Quick Start Kit (4WCC4–A1)(4TCC4–A1) BAYQSTK300A [ ]
Quick Start Kit (4YCC4–A1) BAYQSTK301A [ ]
Crankcase Heater Scroll (4*CC4024–036) (4*CY4024–4036) (230v) BAYCCHT103A [ ]
Crankcase Heater Scroll (4*CC4042–060) (4*CY4042–4060) (230v) BAYCCHT102A [ ]
Crankcase Heater Scroll (4*CC4024–036) (4*CY4024–4036) (230v) BAYCCHT301A [ ]
Crankcase Heater Scroll (4*CC4042–060) (4*CY4042–4060) (230v) BAYCCHT302A [ ]
Adapter Curb (4*CC4024–36A) (4*CY4024–4036A) to BAYCURB030,38 BAYADAP050A [ ]
Adapter Curb (4*CC4024–36A) (4*CY4024–4036A) to BAYCURB033 BAYADAP051A [ ]
Adapter Curb (4*CC4042–60A) (4*CY4042–4060A) to BAYCURB030,38 BAYADAP052A [ ]
Adapter Curb (4*CC4042–60A) (4*CY4042–4060A) to BAYCURB033 BAYADAP053A [ ]
Adapter Curb (4*CC4042–60A) (4*CY4042–4060A) to BAYCURB034 BAYADAP054A [ ]
12” Duct Shroud Covers Horizontal (4*CC4024–060A) (4*CY4024–4060A) BAYCOVR112A [ ]
18” Duct Shroud Covers Horizontal (4*CC4024–060A) (4*CY4042–4060A) BAYCOVR118A [ ]
Extreme Condition Mounting Kit — All BAYCURB & BAYADAP BAYEXMK001A [ ]
Extreme Condition Mounting Kit — All BAYUTIL BAYEXMK002B [ ]
Extreme Condition Mounting Kit — All Slab Mounts BAYEXMK003B [ ]
Lifting Lug Kit BAYLIFT002B [ ]
LP Conversion Kit (All 115K Models) BAYLPKT100A [ ]
LP Conversion Kit (All 60K and 90K Models) BAYLPKT101A [ ]
LP Conversion Kit (All 70K Models) BAYLPKT102A [ ]
SUPPLEMENTARY HEATERS (1 PHASE) * = T or W Only (Does not apply to Gas/Electric dual fuel models)
3.76/5.0 KW Heater (208/240V 1 PH) (4*CC4024–060A1) BAYHTRV105F [ ]
6.0/8.0 KW Heater (208/240V 1 PH) (4*CC4024–060A1) BAYHTRV108F [ ]
7.50/10.0 KW Heater (208/240V 1 PH) (4*CC4024–060A1) BAYHTRV110F [ ]
11.27/15.0 KW Heater (208/240V 1 PH) (4*CC4030–060A1) BAYHTRV115F [ ]
15.0/20.0 KW Heater (208/240V 1 PH) (4*CC4048–060A1) BAYHTRV120F [ ]
18.78/25.0 KW Heater (208/240V 1 PH) (4*CC40060A1) BAYHTRV125F [ ]
6 22-1901-1J-EN
Optional Equipment Listing
SUPPLEMENTARY HEATERS (3 PHASE) * = T or W Only (Does not apply to Gas/Electric dual fuel models)
3.76/5.0 KW Heater (208/240V 3 PH) (4WCY4036–060A3) BAYHTRV305F [ ]
3.76/5.0 KW Heater (208/240V 3 PH) (4WCY4036–060A3) BAYHTRV308F [ ]
7.50/10.0 KW Heater (208/240V 3 PH) (4WCY4024–048A3) BAYHTRV310F [ ]
11.27/15.0 KW Heater (208/240V 3 PH) (4WCY4036–060A3) BAYHTRV315F [ ]
15.0/20.0 KW Heater (208/240V 3 PH) (4WCY4048–060A3) BAYHTRV320F [ ]
18.78/25.0 KW Heater (208/240V 3 PH) (4WCY4048–060A1) BAYHTRV325F [ ]
Single Power Entry Kit (e) BAYSPEK060F [ ]
Single Power Entry Kit (e) BAYSPEK061E [ ]
Single Power Entry Kit (e) BAYSPEK062F [ ]
Single Power Entry Kit (e) BAYSPEK063F [ ]
Single Power Entry Kit (e) BAYSPEK064E [ ]
Single Power Entry Kit (e) BAYSPEK065E [ ]
(a) Must use internal filter frame when economizer or fresh air kit is used.
(b) It is the responsibility of the installing dealer to properly size the ductwork for each specific application.
(c) Dry bulb control standard with economizer.
(d) Downflow only.
(e) Must be selected per unit and heater model
22-1901-1J-EN 7
Product Specifications
MODEL 4YCC4024A1060A 4YCC4030A1070A 4YCC4036A1070A 4YCC4036A1090A
RATED Volts/PH/Hz 208–230/1/60 208–230/1/60 208–230/1/60 208–230/1/60
Performance Cooling BTUH (a) 24600 28200 37000 37000
Indoor Airflow (CFM) 805 870 1190 1190
Power Input (KW) 1.99 2.39 3.08 3.08
EER/SEER (BTU/Watt-Hr.) 12.0 / 14.00 12.0 / 14.00 12.0 / 14.00 12.0 / 14.00
Sound Power Rating [dB(A)]
(b) 66.6 70.0 69.3 69.3
PERFORMANCE HEATING(c)
Input BTUH-1st Stage
60000 70000 70000 90000
(Natural Gas) (d)
AFUE 81 81 81 81
Temp. Rise — Min/Max (°F) 30 / 60 30 / 60 30 / 60 35 / 65
Orifice Qty/Drill Sz. (Natural
2 / #37 2 / #33 2 / #33 3 / #37
Gas)
POWER CONN. — V/Ph/Hz 208–230/1/60 208–230/1/60 208–230/1/60 208–230/1/60
Min. Brch. Cir. Ampacity (e) 19.1 22.6 24.5 24.5
Fuse Size — Max. (amps) 30 35 40 40
Fuse Size — Recmd. (amps) 30 35 40 40
COMPRESSOR SCROLL SCROLL SCROLL SCROLL
VOLTS/PH/HZ 208–230/1/60 208–230/1/60 208–230/1/60 208–230/1/60
R.L. Amps — L.R. Amps 12.8 / 58.3 14.1 / 73.0 15.4 / 83.9 15.4 / 83.9
OUTDOOR COIL — TYPE SPINE-FIN SPINE-FIN SPINE-FIN SPINE-FIN
Rows/F.P.I 2 / 24 2 / 24 2 / 24 2 / 24
Face Area (sq. ft.) 13.32 13.32 15.49 15.49
Tube Size (in.) 3/8 3/8 3/8 3/8
INDOOR COIL — TYPE MCHE MCHE MCHE MCHE
Rows/F.P.I 2 / 16 2 / 16 2 / 16 2 / 16
Face Area (sq. ft.) 2.7 2.7 2.7 2.7
Tube Size Width (in.) .81 .81 1” 1”
Refrigeration Control EXPANSION VALVE EXPANSION VALVE EXPANSION VALVE EXPANSION VALVE
Drain Conn. Size (in.) 3/4 FEMALE NPT 3/4 FEMALE NPT 3/4 FEMALE NPT 3/4 FEMALE NPT
OUTDOOR FAN — TYPE SWEPT SWEPT SWEPT SWEPT
DIA. (IN.) 23.4 23.4 23.4 23.4
DRIVE/NO. SPEEDS DIRECT / 1 DIRECT / 1 DIRECT / 1 DIRECT / 1
CFM @ 0.0 in. w.g. (f) 2350 2800 3080 3080
Motor — HP/R.P.M 1/12 / 810 1/6/ 825 1 / 5 / 825 1 / 5 / 825
Volts/Ph/Hz 208–230/1/60 208–230/1/60 208–230 / 1 / 60 208–230 / 1 / 60
F.L. Amps/L.R Amps .54 / .82 .85 / 1.65 1.1 / 2.0 1.1 / 2.0
INDOOR FAN — TYPE CONSTANT TORQUE ECM CONSTANT TORQUE ECM CONSTANT TORQUE ECM CONSTANT TORQUE ECM
Dia. x Width (in.) 10.62 X 10.62 10.62 X 10.62 10.62 X 10.62 10.62 X 10.62
Drive/No. Speeds DIRECT–3 DIRECT–3 DIRECT–3 DIRECT–3
CFM @ 0.0 in. w.g. (g) SEE FAN PERF TABLE SEE FAN PERF TABLE SEE FAN PERF TABLE SEE FAN PERF TABLE
Motor — HP/R.P.M. 1/3 / 1050 1/2 / 1050 1/2 / 1050 1/2 / 1050
Volts/Ph/Hz 208–230/1/60 208–230/1/60 208–230/1/60 208–230/1/60
F.L. Amps 2.6 4.1 4.1 4.1
COMBUSTION FAN — TYPE CENTRIFUGAL CENTRIFUGAL CENTRIFUGAL CENTRIFUGAL
Drive/No. Speeds DIRECT / 1 DIRECT / 1 DIRECT / 1 DIRECT / 1
8 22-1901-1J-EN
Product Specifications
22-1901-1J-EN 9
Product Specifications
10 22-1901-1J-EN
Product Specifications
22-1901-1J-EN 11
Product Specifications
12 22-1901-1J-EN
Indoor Fan Performance
Table 1. Horizontal Airflow
4YCC4024A1060A EXTERNAL STATIC PRESSURE (IN. WG)
Tap
MOTOR SPEED 0 0.1 0.2 0.3 0.4 0.5 0.6 0.7 0.8 0.9 1
Number
CONSTANT CFM
1 APPROXIMATELY 40 - 50 % COOLING OR HEATING AIRFLOW
CIRCULATION WATTS
CFM 954 900 846 794 729 650 588 535 488 — —
COOLING-LOW 2
WATTS 107 114 121 128 138 147 152 157 161 — —
CFM 1041 993 938 890 836 777 707 644 594 — —
COOLING-HIGH 3
WATTS 135 142 150 158 167 175 185 191 196 — —
CFM 1123 1059 994 943 889 — — — — — —
HEAT-LOW 4
WATTS 143 152 160 167 175 — — — — — —
CFM — — 1122 1069 1022 974 922 871 809 — —
HEAT-HIGH 5
WATTS — — 213 221 229 238 245 253 261 — —
Tap
MOTOR SPEED 0 0.1 0.2 0.3 0.4 0.5 0.6 0.7 0.8 0.9 1
Number
CONSTANT CFM
1 APPROXIMATELY 40 - 50 % COOLING OR HEATING AIRFLOW
CIRCULATION WATTS
22-1901-1J-EN 13
Indoor Fan Performance
Tap
MOTOR SPEED 0 0.1 0.2 0.3 0.4 0.5 0.6 0.7 0.8 0.9 1
Number
CONSTANT CFM
1 APPROXIMATELY 40 - 50 % COOLING OR HEATING AIRFLOW
CIRCULATION WATTS
CFM 1256 1223 1193 1167 1136 1101 1065 1026 955 — —
COOLING-LOW 2
WATTS 339 350 358 366 374 383 391 399 386 — —
CFM 1185 1141 1099 1055 1009 968 920 854 808 731 624
HEAT-LOW 4
WATTS 241 251 260 270 279 289 299 311 320 306 284
CFM 1386 1354 1311 1276 1238 1198 1164 1069 805 689 596
HEAT-HIGH 5
WATTS 386 399 409 419 430 441 452 432 320 303 298
CONSTANT CFM
1 APPROXIMATELY 40 - 50 % COOLING OR HEATING AIRFLOW
CIRCULATION WATTS
CFM 1288 1254 1225 1193 1158 1117 1070 956 806 639 —
COOLING-LOW 2
WATTS 340 348 357 366 375 385 395 365 320 273 —
CFM 1358 1326 1300 1271 1241 1201 1107 933 739 643 —
COOLING-HIGH 3
WATTS 402 410 419 427 437 447 423 361 293 271 —
CFM 1292 1259 1230 1199 1163 1124 1071 963 799 638 —
HEAT-LOW 4
WATTS 343 351 360 369 378 388 398 370 316 293 —
CFM 1367 1341 1310 1282 1250 1212 1075 928 781 631 —
HEAT-HIGH 5
WATTS 404 413 421 431 439 448 404 346 302 282 —
Tap
MOTOR SPEED 0 0.1 0.2 0.3 0.4 0.5 0.6 0.7 0.8 0.9 1
Number
CONSTANT CFM
1 APPROXIMATELY 40 - 50 % COOLING OR HEATING AIRFLOW
CIRCULATION WATTS
14 22-1901-1J-EN
Indoor Fan Performance
CFM 1173 1130 1088 1044 999 958 911 846 800 724 618
HEAT-LOW 4
WATTS 238 248 258 267 277 286 296 308 316 303 282
CFM 1373 1340 1298 1263 1225 1186 1153 1058 797 682 590
HEAT-HIGH 5
WATTS 382 395 405 415 425 437 448 428 317 300 295
CONSTANT CFM
1 APPROXIMATELY 40 - 50 % COOLING OR HEATING AIRFLOW
CIRCULATION WATTS
CFM 1350 1320 1294 1263 1234 1196 1102 928 735 — —
COOLING-HIGH 3
WATTS 402 410 419 427 437 447 423 361 293 — —
CFM 1285 1252 1222 1186 1148 1111 1060 954 781 — —
HEAT-LOW 4
WATTS 343 351 360 369 378 388 398 370 316 — —
Tap
MOTOR SPEED 0 0.1 0.2 0.3 0.4 0.5 0.6 0.7 0.8 0.9 1
Number
CONSTANT CFM
1 APPROXIMATELY 40 - 50 % COOLING OR HEATING AIRFLOW
CIRCULATION WATTS
CFM 1358 1393 1348 1296 1253 1204 1157 1096 1057 988 —
COOLING-LOW 2
WATTS 224 233 242 252 262 272 283 295 305 319 —
CFM 1521 1490 1448 1391 1362 1338 1315 1307 1254 1148 —
COOLING-HIGH 3
WATTS 306 316 327 337 348 359 369 382 395 407 —
CONSTANT CFM
1 APPROXIMATELY 40 - 50 % COOLING OR HEATING AIRFLOW
CIRCULATION WATTS
CFM 1358 1393 1348 1296 1253 1204 1157 1096 1057 988 —
COOLING-LOW 2
WATTS 224 233 242 252 262 272 283 295 305 319 —
CFM 1521 1490 1448 1391 1362 1338 1315 1307 1254 1148 —
COOLING-HIGH 3
WATTS 306 316 327 337 348 359 369 382 395 407 —
22-1901-1J-EN 15
Indoor Fan Performance
CFM 1559 1524 1483 1443 1401 1363 1319 1276 1233 1195 1147
HEAT-HIGH 5
WATTS 313 324 335 346 356 367 379 392 403 415 428
Tap
MOTOR SPEED 0 0.1 0.2 0.3 0.4 0.5 0.6 0.7 0.8 0.9 1
Number
CONSTANT CFM
1 APPROXIMATELY 40 - 50 % COOLING OR HEATING AIRFLOW
CIRCULATION WATTS
CFM 1345 1379 1334 1283 1241 1192 1145 1085 1046 979 —
COOLING-LOW 2
WATTS 228 238 247 257 267 278 289 301 312 325 —
CFM 1506 1475 1433 1377 1348 1325 1302 1293 1241 1136 —
COOLING-HIGH 3
WATTS 312 322 333 344 354 366 377 389 403 415 —
CONSTANT CFM
1 APPROXIMATELY 40 - 50 % COOLING OR HEATING AIRFLOW
CIRCULATION WATTS
CFM 1345 1379 1334 1283 1241 1192 1145 1085 1046 979 —
COOLING-LOW 2
WATTS 228 238 247 257 267 278 289 301 312 325 —
CFM 1506 1475 1433 1377 1348 1325 1302 1293 1241 1136 —
COOLING-HIGH 3
WATTS 312 322 333 344 354 366 377 389 403 415 —
CFM 1426 1387 1348 1301 1255 1210 1166 1120 1074 1020 966
HEAT-LOW 4
WATTS 241 251 260 270 281 292 303 314 325 335 349
CFM 1567 1531 1491 1450 1408 1370 1326 1282 1239 1201 1152
HEAT-HIGH 5
WATTS 315 325 337 347 358 368 381 394 405 417 430
Tap
MOTOR SPEED 0 0.1 0.2 0.3 0.4 0.5 0.6 0.7 0.8 0.9 1
Number
CONSTANT CFM
1 APPROXIMATELY 40 - 50 % COOLING OR HEATING AIRFLOW
CIRCULATION WATTS
CFM 1583 1542 1502 1460 1415 1371 1326 1282 1230 1181 —
COOLING-LOW 2
WATTS 302 313 324 332 345 353 368 376 394 406 —
CFM 1763 1723 1689 1648 1609 1568 1527 1488 1447 1404 —
COOLING-HIGH 3
WATTS 414 426 436 448 459 471 483 495 510 524 —
16 22-1901-1J-EN
Indoor Fan Performance
CONSTANT CFM
1 APPROXIMATELY 40 - 50 % COOLING OR HEATING AIRFLOW
CIRCULATION WATTS
CFM 1583 1542 1502 1460 1415 1371 1326 1282 1230 1181 —
COOLING-LOW 2
WATTS 302 313 324 332 345 353 368 376 394 406 —
CFM 1763 1723 1689 1648 1609 1568 1527 1488 1447 1404 —
COOLING-HIGH 3
WATTS 414 426 436 448 459 471 483 495 510 524 —
CFM 1419 1380 1341 1295 1249 1204 1160 1115 1069 1015 961
HEAT-LOW 4
WATTS 240 250 259 269 279 291 302 312 323 333 348
CFM 1559 1524 1483 1443 1401 1363 1319 1276 1233 1195 1147
HEAT-HIGH 5
WATTS 313 324 335 346 356 367 379 392 403 415 428
Tap
MOTOR SPEED 0 0.1 0.2 0.3 0.4 0.5 0.6 0.7 0.8 0.9 1
Number
CONSTANT CFM
1 APPROXIMATELY 40 - 50 % COOLING OR HEATING AIRFLOW
CIRCULATION WATTS
CFM 1567 1526 1487 1445 1401 1358 1312 1270 1218 1169 —
COOLING-LOW 2
WATTS 308 320 330 339 352 360 375 384 402 413.9 —
CFM 1745 1706 1672 1632 1593 1552 1512 1473 1433 1390 —
COOLING-HIGH 3
WATTS 422 434 444 457 468 480 493 505 520 534 —
CONSTANT CFM
1 APPROXIMATELY 40 - 50 % COOLING OR HEATING AIRFLOW
CIRCULATION WATTS
CFM 1567 1526 1487 1445 1401 1358 1312 1270 1218 1169 —
COOLING-LOW 2
WATTS 308 320 330 339 352 360 375 384 402 413.9 —
CFM 1745 1706 1672 1632 1593 1552 1512 1473 1433 1390 —
COOLING-HIGH 3
WATTS 422 434 444 457 468 480 493 505 520 534 —
CFM 1426 1387 1348 1301 1255 1210 1166 1120 1074 1020 966
HEAT-LOW 4
WATTS 241 251 260 270 281 292 303 314 325 335 349
CFM 1567 1531 1491 1450 1408 1370 1326 1282 1239 1201 1152
HEAT-HIGH 5
WATTS 315 325 337 347 358 368 381 394 405 417 430
22-1901-1J-EN 17
Indoor Fan Performance
Tap
MOTOR SPEED 0 0.1 0.2 0.3 0.4 0.5 0.6 0.7 0.8 0.9 1
Number
CONSTANT CFM
1 APPROXIMATELY 40 - 50 % COOLING OR HEATING AIRFLOW
CIRCULATION WATTS
CFM 2083 2058 2032 2003 1974 1943 1911 1877 1843 1807 —
COOLING-HIGH 3
WATTS 749 759 769 779 788 803 816 830 845 860 —
CFM — 1594 1551 1511 1471 1430 1386 1344 1305 1265 —
HEAT-HIGH 5
WATTS — 348 361 373 384 396 409 420 432 443 —
CONSTANT CFM
1 APPROXIMATELY 40 - 50 % COOLING OR HEATING AIRFLOW
CIRCULATION WATTS
CFM 2083 2058 2032 2003 1974 1943 1911 1877 1843 1807 —
COOLING-HIGH 3
WATTS 749 759 769 779 788 803 816 830 845 860 —
CFM — 1927 1894 1861 1824 1788 1750 1711 1674 1639 —
HEAT-HIGH 5
WATTS — 614 627 639 651 664 677 689 702 715
Tap
MOTOR SPEED 0 0.1 0.2 0.3 0.4 0.5 0.6 0.7 0.8 0.9 1
Number
CONSTANT CFM
1 APPROXIMATELY 40 - 50 % COOLING OR HEATING AIRFLOW
CIRCULATION WATTS
CFM 2083 2058 2032 2003 1974 1943 1911 1877 1843 1807 —
COOLING-HIGH 3
WATTS 749 759 769 779 788 803 816 830 845 860 —
CFM — 1602 1558 1518 1478 1437 1392 1351 1311 1271 —
HEAT-HIGH 5
WATTS — 350 363 374 386 398 411 423 434 445 —
CONSTANT CFM
1 APPROXIMATELY 40 - 50 % COOLING OR HEATING AIRFLOW
CIRCULATION WATTS
18 22-1901-1J-EN
Indoor Fan Performance
CFM 2083 2058 2032 2003 1974 1943 1911 1877 1843 1807 —
COOLING-HIGH 3
WATTS 749 759 769 779 788 803 816 830 845 860 —
CFM — 1910 1875 1839 1803 1773 1736 1704 1661 1622 —
HEAT-HIGH 5
WATTS — 630 634 647 660 672 685 698 712 726 —
22-1901-1J-EN 19
Field Wiring Diagram
Figure 1. 4YCC4 — Field Wiring Diagram
COMMON
FAN (GR)
(CONSTANT CIRCULATION)
CONTACTOR/COMPRESSOR/FAN
DWG. C757192REVA
Notes:
1. FUSED DISCONNECT SIZE, POWER WIRING AND GROUNDING
OF EQUIPMENT MUST COMPLY WITH CODES.
20 22-1901-1J-EN
Wiring — 4YCC4
Figure 2. 4YCC4024–042
Drw. D758084P01
22-1901-1J-EN 21
Wiring — 4YCC4
Figure 3. 4YCC4024–042
22 22-1901-1J-EN
Wiring — 4YCC4
Figure 4. 4YCC4048
Drw. D758082P01
22-1901-1J-EN 23
Wiring — 4YCC4
Figure 5. 4YCC4048
24 22-1901-1J-EN
Wiring — 4YCC4
Figure 6. 4YCC4060
Drw. D758083P01
22-1901-1J-EN 25
Wiring — 4YCC4
Figure 7. 4YCC4060
26 22-1901-1J-EN
Full Perimeter Roof Mounting Curb
Figure 8. 2.0 — 3.0 Ton Models
17 7/8
46 3/8
3
RETURN 3 5/8
AIR
SUPPLY
AIR
19 1/2
2 3/16
19 1/2
15
38 7/8
1 1/2
RETURN
AIR
SUPPLY
AIR
CHANNEL SIDE
CHANNEL END
WOOD NAILER
HOLE IN ROOF A B C D
43 3/8
35 7/8
** 42.00 WITH ECONOMIZER WITH 25% FRESH
AIR ACCESSORY
22-1901-1J-EN 27
Full Perimeter Roof Mounting Curb
15 7/8
56 1/8
3
RETURN
AIR
1 1/2 SUPPLY
AIR 10 7/8
19 1/2
20 4 3/4
19 1/2
41 7/8
14
RETURN
AIR
SUPPLY
AIR
CHANNEL SIDE
CHANNEL END WOOD NAILER
HOLE IN ROOF
A B C D
WC*/TC* 42.00 36.00 12.00** 24.00
DC*/YC* 42.00 36.00 12.00** 36.00
38 7/8 53 1/8
** 42.00 WITH ECONOMIZER WITH 25% FRESH
AIR ACCESSORY
28 22-1901-1J-EN
Optional Equipment — Economizer
Table 13. BAYECON101,102A Down Discharge Economizer and Rain Hood
(Mounts Over Horizontal Return Air Opening)
Economizer
rain hood
BAYECON101A 2.0 — 3.0 Ton Models
Outside air
dampers
Return air
dampers Required
filter kit, order
Mist separately
eliminator
Relief Return
damper Duct
Roofcurb
Economizer
A
B
D
C
Gaskets (2)
E Rain Hood
Duct
Mixed Air
Sensor
Economizer Models A B C D E F
BAYECON200A 2.0 — 3.0 Ton 22” 20” 16–7/8” 15–11/16” 11–11/16” 15”
BAYECON201A 3.5 — 5.0 Ton 26” 22–21/32” 19” 17–11/16” 14–11/16” 21–3/8”
Note: The drawings on this page are prepared by the manufacturer in order to provide detail regarding job layout only. These drawings are not
intended to be used as a basis to construct, build or modify the items depicted in the drawings. The manufacturer is not responsible for
the unauthorized use of these drawings and expressly disclaims any liability for damages resulting from such unauthorized use.
22-1901-1J-EN 29
Optional Equipment — Outside Air Damper
Table 15. BAYOSAH001 and 002A
Unit
Manual Fresh
Application A B C D
Air Model
A Models
FULLY
OPEN BAYOSAH001A 2.0 — 3.0 Ton 22–7/16” 20–11/16” 12–3/8” 9–3/16”
2/3
D C 1/3
B FULLY
CLOSED
Table 16. BAYDMPR101 and 102A, 25% Motorized Outside Air Damper
(Mounts Over Horizontal Return Air Opening)
Manual Unit
Fresh Air Application A B C D E
A
Model Models
B
C
Note: The drawings on this page are prepared by the manufacturer in order to provide detail regarding job layout only. These drawings are not
intended to be used as a basis to construct, build or modify the items depicted in the drawings. The manufacturer is not responsible for
the unauthorized use of these drawings and expressly disclaims any liability for damages resulting from such unauthorized use.
30 22-1901-1J-EN
Optional Equipment — Filter Rack
Figure 10. BAYFLTR101 Filter Rack (2.0 – 3.0 Ton Models)
BAYFLTR201 (3.5 – 5.0 Ton Models)
(Mounts in Filter/Coil Section)
Figure 11. BAYACCDOR1A Hinged Filter Access Door (2.0 – 3.0 Ton Models)
BAYACCDOR2A (3.5 – 5.0 Ton Models)
Replaces Filter/Coil Access Panel
Note: The drawings on this page are prepared by the manufacturer in order to provide detail regarding job layout only. These drawings are not
intended to be used as a basis to construct, build or modify the items depicted in the drawings. The manufacturer is not responsible for
the unauthorized use of these drawings and expressly disclaims any liability for damages resulting from such unauthorized use.
22-1901-1J-EN 31
Outline Drawings
Figure 12. 4YCC4024–4036
1049.02
[41-5/16]
32 22-1901-1J-EN
Outline Drawings
Height mm/in Flu Hood w/brkt Approx. Corner Weight - kg / lbs Shipping Total Unit Center of Gravity mm/in
mm/in
Weight Weight
A D W1 W2 W3 W4 kg/lbs kg/lbs B C
4YCC4024 (060) 898.53 [35-3/8] 157.16 [6-3/16] 58.3 [129] 36.8 [81] 26.1 [58] 41.0 [90] 196.1 [432] 162.4 [358] 479.8 [18.9] 527.8 [20.8]
4YCC4030 (070) 898.53 [35-3/8] 157.16 [6-3/16] 61.3 [135] 38.7 [85] 27.5 [61] 43.1 [95] 204.8 [451] 171.1 [377] 406.5 [16.0] 594.1 [23.4]
4YCC4036 (070) 949.33 [37-3/8] 157.16 [6-3/16] 61.1 [134] 38.3 [84] 27.1 [60] 43.2 [95] 203.4 [438] 169.7 [374] 414.3 [16.3] 697.6 [27.5]
4YCC4036 (090) 949.53 [37-3/8] 157.16 [6-3/16] 61.7 [136] 38.9 [86] 27.7 [61] 43.7 [96] 205.7 [453] 172.0 [379] 414.3 [16.3] 697.6 [27.5]
22-1901-1J-EN 33
Outline Drawings
34 22-1901-1J-EN
Outline Drawings
22-1901-1J-EN 35
Outline Drawings
Height mm/in Approx. Corner Weight - kg / lbs Shipping Total Unit Center of Gravity mm/in
Model Weight Weight
A W1 W2 W3 W4 kg/lbs kg/lbs B C
4YCC4042 (060) 898.53 [35-3/8] 71.2 [157] 46.6 [103] 34.6 [76] 53.1 [117] 252.2 [555] 202.0 [452] 470.0 [18.5] 731.0 [28.8]
4YCC4042 (090) 898.53 [35-3/8] 71.8 [158] 47.2 [104] 35.2 [78] 53.6 [118] 254.5 [561] 207.3 [457] 470.0 [18.5] 731.0 [28.8]
4YCC4048 (070) 1000.13 [39-3/8] 71.4 [157] 44.6 [98] 33.2 [73] 53.9 [119] 250.3 [552] 202.1 [448] 433.0 [17.0] 743.3 [29.3]
4YCC4048 (090) 1000.13 [39-3/8] 72.0 [159] 45.0 [99] 33.8 [75] 54.4 [120] 252.6 [557] 205.4 [453] 433.0 [17.0] 743.3 [29.3]
4YCC4060 (090) 1000.13 [39-3/8] 77.1 [170] 45.8 [101] 34.4 [76] 58.3 [128] 263.1 [580] 215.9 [476] 433.0 [17.0] 743.3 [29.3]
4YCC4060 (115) 1000.13 [39-3/8] 78.0 [172] 46.3 [102] 34.9 [77] 59.0 [130] 265.8 [586] 218.6 [482] 414.0 [16.3] 635.0 [25.0]
36 22-1901-1J-EN
Outline Drawings
22-1901-1J-EN 37
Notes
38 22-1901-1J-EN
Notes
22-1901-1J-EN 39
Trane - by Trane Technologies (NYSE: TT), a global innovator - creates comfortable, energy efficient indoor
environments for commercial and residential applications. For more information, please visit trane. com or
tranetechnologies.com.
The AHRI Certified mark indicates Trane U.S. Inc. participation in the AHRI Certification program. For verification of individual certified products, go to ahridirectory.
org.
Trane has a policy of continuous data improvement and it reserves the right to change design and specifications without notice. We are committed to using
environmentally conscious print practices.