Safety Data Sheet: Extreme Simple Green® Aircraft & Precision Cleaner [ready to use]

Version No. 00151-16A Issue Date: February 23, 2016 Supersedes Date: October 5, 2015 OSHA HCS-2012 / GHS

Section 1: IDENTIFICATION
Product Name: Extreme Simple Green® Aircraft & Precision Cleaner
Additional Names:
Manufacturer’s Part Number: *Please refer to Section 16
Recommended Use: Cleaner and degreaser formulated to safely remove, oil, grease, and grime.
Restrictions on Use: Do not use on non-rinsable or asphalt surfaces
Company: Sunshine Makers, Inc. Telephone: 800-228-0709 ● 562-795-6000 Mon – Fri, 8am – 5pm PST
15922 Pacific Coast Highway Fax: 562-592-3830
Huntington Beach, CA 92649 USA Email: info@simplegreen.com
Emergency Phone: Chem-Tel 24-Hour Emergency Service: 800-255-3924

Section 2: HAZARDS IDENTIFICATION

This product is considered hazardous (Eye Corrosive/Irritant – Category 2B) by the 2012 OSHA Hazard Communication Standard (29
CFR 1910.1200)
OSHA HCS 2012
Label Elements
Signal Word: Warning Hazard Symbol(s)/Pictogram(s): None required
Hazard Statements:
H320 – Causes Eye Irritation.
Precautionary Statements:
P264 – Wash hands thoroughly after handling.
P305+P351+P338 – IF IN EYES: Rinse cautiously with water for several minutes. Remove contact lenses, if present and easy to do.
Continue rinsing.
P337+P313 – If eye irritation persists: Get medical advice.
Hazards Not Otherwise Classified (HNOC): No hazards not otherwise classified were identified
Other Information: None Known.

Section 3: COMPOSITION/INFORMATION ON INGREDIENTS

Ingredient CAS Number Percent Range
Water 7732-18-5 > 91%*
Triethanolamine 102-71-6 ≤ 3%*
Ethoxylated Alcohol 68439-46-3 ≤ 3%*
Propylene Glycol Butyl Ether 5131-66-8 < 1%*
Tetrapotassium Pyrophosphate 7320-34-5 < 1%*
Potassium Silicate 1312-76-1 < 1%*
*specific percentages of composition are being withheld as a trade secret

Section 4: FIRST-AID MEASURES

Inhalation: Not expected to cause respiratory irritation. If adverse effect occurs, move to fresh air.
Skin Contact: Not expected to cause skin irritation. If adverse effect occurs, rinse skin with water.
Eye Contact: Rinse cautiously with water for several minutes. Remove contact lenses, if present and easy to do. Continue rinsing.
If eye irritation persists: Get medical advice.
Ingestion: May cause upset stomach. Drink plenty of water to dilute. See section 11.
Most Important Symptoms/Effects, Acute and Delayed: None known.
Indication of Immediate Medical Attention and Special Treatment Needed, if necessary: Treat symptomatically

Page 1 of 5
Safety Data Sheet: Extreme Simple Green® Aircraft & Precision Cleaner [ready to use]
Version No. 00151-16A Issue Date: February 23, 2016 Supersedes Date: October 5, 2015 OSHA HCS-2012 / GHS

Section 5: FIRE-FIGHTING MEASURES

Suitable & Unsuitable Extinguishing Media: Use Dry chemical, CO2, water spray or “alcohol” foam. Avoid high volume jet water.
Specific Hazards Arising from Chemical: In event of fire, fire created carbon oxides and oxides of phosphorus may be formed.
Special Protective Actions for Fire-Fighters: Wear positive pressure self-contained breathing apparatus; Wear full protective
clothing.

This product is non-flammable. See Section 9 for Physical Properties.

Section 6: ACCIDENTAL RELEASE MEASURES

Personal Precautions, Protective Equipment and Emergency Procedures:
For non-emergency personnel: See section 8 – personal protection.
For emergency responders: Avoid eye contact. Safety goggles suggested if splashing or misting is likely to occur.

Environmental Precautions: Do not allow into open waterways and ground water systems.

Methods and Materials for Containment and Clean Up: Dike or soak up with inert absorbent material. See section 13 for disposal
considerations.

Section 7: HANDLING AND STORAGE

Precautions for Safe Handling: Ensure adequate ventilation. Keep out of reach of children. Keep away from heat, sparks, open flame
and direct sunlight. Do not pierce any part of the container. Do not mix or contaminate with any other chemical. Do not eat, drink or
smoke while using this product.

Conditions for Safe Storage including Incompatibilities: Keep container tightly closed. Keep in cool dry area. Avoid prolonged
exposure to sunlight. Do not store at temperatures above 109oF (42.7oC). If separation occurs, mix the product for reconstitution.

Section 8: EXPOSURE CONTROLS / PERSONAL PROTECTION

Exposure Limit Values: Triethanolamine (102-71-6) 5 mg/m3 PEL California
Diethanolamine (111-42-2) 3 ppm TWA; 15 mg/m3 TWA Connecticut, Michigan, Minnesota, OSHA,
Tennessee, Vermont, Washington
0.46 ppm PEL; 2 mg/m3 PEL California
6 ppm STEL Washington
Appropriate Engineering Controls: Showers, eyewash stations, ventilation systems

Individual Protection Measures / Personal Protective Equipment (PPE)

Eye Contact: Use protective glasses or safety goggles if splashing or spray-back is likely.
Respiratory: Use in well ventilated areas or local exhaust ventilations when cleaning small spaces.
Skin Contact: Use protective gloves (any material) when used for prolonged periods or dermally sensitive.
General Hygiene Considerations: Wash thoroughly after handling and before eating or drinking.

Section 9: PHYSICAL AND CHEMICAL PROPERTIES

Appearance: Clear Liquid Partition Coefficient: n-octanol/water: Not determined
Odor: No added odor Autoignition Temperature: Non-flammable
Odor Threshold: Not determined Decomposition Temperature: 109oF
pH: 9.0 – 10.5 Viscosity: Like water
Freezing Point: 0oC (32oF) Specific Gravity : 1.01 – 1.04
Boiling Point & Range: 98oC (210oF) VOCs: **Water & fragrance exemption in calculation
Flash Point: > 212oF SCAQMD 304-91 / EPA 24: Not tested
Evaporation Rate: Not determined CARB Method 310**: 5 g/L 0.042 lb/gal 0.5%
Flammability (solid, gas): Not applicable SCAQMD Method 313: 5.1 g/L 0.042 lb/gal 0.51%
Upper/Lower Flammability or Explosive Limits: Not applicable VOC Composite Partial Pressure: Not determined
Page 2 of 5
Safety Data Sheet: Extreme Simple Green® Aircraft & Precision Cleaner [ready to use]
Version No. 00151-16A Issue Date: February 23, 2016 Supersedes Date: October 5, 2015 OSHA HCS-2012 / GHS

Section 9: PHYSICAL AND CHEMICAL PROPERTIES - continued

Vapor Pressure : Not determined Nutrient Content:
Vapor Density: Not determined Nitrogen - <0.1% (0% by formula)
Relative Density: 8.34 – 8.67 lb/gal Phosphorous - < 0.25% (by formula)
Solubility: 100% in water Sulfur - <0.1% (0% by formula)

Section 10: STABILITY AND REACTIVITY

Reactivity: Non-reactive.
Chemical Stability: Stable under normal conditions 70oF (21oC) and 14.7 psig (760 mmHg).
Possibility of Hazardous Reactions: None known.
Conditions to Avoid: Excessive heat or cold.
Incompatible Materials: Do not mix with oxidizers, acids, bathroom cleaners, or disinfecting agents.
Hazardous Decomposition Products: Normal products of combustion - CO, CO2, oxides of phosphorus.

Section 11: TOXICOLOGICAL INFORMATION

Likely Routes of Exposure: Inhalation - Overexposure may cause headache.
Skin Contact - Not expected to cause irritation.
Eye Contact - Causes minimal/mild eye irritation.
Ingestion - May cause upset stomach.

Symptoms related to the physical, chemical and toxicological characteristics: no symptoms expected under typical use conditions.
Delayed and immediate effects and or chronic effects from short term exposure: no symptoms expected under typical use conditions.
Delayed and immediate effects and or chronic effects from long term exposure: headache, dry skin, or skin irritation may occur.
Interactive effects: Not known.

Numerical Measures of Toxicity

Acute Toxicity: Oral LD 50 (rat) > 5 g/kg body weight
Dermal LD 50 (rabbit) > 5 g/kg body weight
Calculated via OSHA HCS 2012 / Globally Harmonized System of Classification and Labelling of Chemicals

Skin Corrosion/Irritation: Non-irritant per Dermal Irritection® assay modeling. No animal testing performed.
Eye Damage/Irritation: Minimal/Mild irritant per Ocular Irritection® assay modeling. No animal testing performed.
Germ Cell Mutagenicity: Mixture does not classify under this category.
Carcinogenicity: Volume of ingredients does not trigger or classify under this category. This product contains trace
amounts of Diethanolamine (IARC 2B and ACGIH A3)
Reproductive Toxicity: Mixture does not classify under this category.
STOT-Single Exposure: Mixture does not classify under this category.
STOT-Repeated Exposure: Mixture does not classify under this category.
Aspiration Hazard: Mixture does not classify under this category.

Section 12: ECOLOGICAL INFORMATION

Ecotoxicity: Volume of ingredients used does not trigger toxicity classifications under the Globally Harmonized System of
Classification and Labelling of Chemicals.
Aquatic: Not tested on finished formulation.
Terrestrial: Not tested on finished formulation.

Persistence and Degradability: Based on similar formulations, expected to be Readily Biodegradable

Bioaccumulative Potential: No data available.
Mobility in Soil: No data available.
Other Adverse Effects: No data available.

Page 3 of 5
Safety Data Sheet: Extreme Simple Green® Aircraft & Precision Cleaner [ready to use]
Version No. 00151-16A Issue Date: February 23, 2016 Supersedes Date: October 5, 2015 OSHA HCS-2012 / GHS

Section 13: DISPOSAL CONSIDERATIONS

Unused or Used Liquid: May be considered hazardous in your area depending on usage and tonnage of disposal – check with local,
regional, and or national regulations for appropriate methods of disposal.

Empty Containers: May be offered for recycling.

Never dispose of used degreasing rinsates into lakes, streams, and open bodies of water or storm drains.

Section 14: TRANSPORT INFORMATION

U.N. Number: Not applicable U.N. Proper Shipping Name: Cleaning Compound, Liquid NOI
Transport Hazard Class(es): Not applicable NMFC Number: 48580-3
Packing Group: Not applicable Class: 55
Environmental Hazards: Marine Pollutant - NO
Transport in Bulk (according to Annex II of MARPOL 73/78 and IBC Code): Unknown.
Special precautions which user needs to be aware of/comply with, in connection None known.
with transport or conveyance either within or outside their premises:

U.S. (DOT) / Canadian TDG: Not Regulated for shipping. ICAO/ IATA: Not classified as Hazardous
IMO / IDMG: Not classified as Hazardous ADR/RID: Not classified as Hazardous

Section 15: REGULATORY INFORMATION

All components are listed on: TSCA and DSL Inventory.

SARA Title III: Sections 311/312 – Not applicable.

Sections 313 Superfunds Amendments and Reauthorizations Act of 1986 – Diethanolamine (111-42-2) < 0.01%
Sections 302 – Not applicable.

Clean Air Act (CAA): Triethanolamine (102-71-6), Diethanolamine (111-42-2), Propylene Glycol Butyl Ether (5131-66-8)
Clean Water Act (CWA): Not applicable
CERCLA: Diethanolamine (111-42-2) 100 lb RQ

State Right To Know Lists: Triethanolamine (102-71-6) Massachusetts, New Jersey, Pennsylvania
Diethanolamine (111-42-2) Massachusetts, New Jersey, Pennsylvania
CA Proposition 65: Diethanolamine (111-42-2) < 0.01%
Texas ESL:
Triethanolamine 102-71-6 5 µg/m3 long term 50 µg/m3 short term
Ethoxylated Alcohol 68439-46-3 60 µg/m3 long term 600 µg/m3 short term
Propylene Glycol Butyl Ether 5131-66-8 73 µg/m3 long term 730 µg/m3 short term
Tetrapotassium Pyrophosphate 7320-34-5 5 µg/m3 long term 50 µg/m3 short term
Potassium Silicate 1312-76-1 5 µg/m3 short term
Diethanolamine 111-42-2 1 µg/m3 long term 10 µg/m3 short term

Section 16: OTHER INFORMATION

Size Item Number UPC
16 oz. 0100000113415 043318000744
16 oz., 12 per case 0110001213415 043318000744
32 oz 0110000113412 043318134128
32 oz, 12 per case 0110001213412 043318134128
275 gallon 13477 043318134777
USA part numbers listed only. Not all part numbers listed. USA part numbers may not be valid for international sale.

Page 4 of 5
Safety Data Sheet: Extreme Simple Green® Aircraft & Precision Cleaner [ready to use]
Version No. 00151-16A Issue Date: February 23, 2016 Supersedes Date: October 5, 2015 OSHA HCS-2012 / GHS

Section 16: OTHER INFORMATION - continued

NFPA:
Health – Eye Irritant Stability – Stable
Flammability – Non-flammable Special - None
Acronyms
NTP National Toxicology Program IARC International Agency for Research on Cancer
OSHA Occupational Safety and Health Administration CPSC Consumer Product Safety Commission
TSCA Toxic Substances Control Act DSL Domestic Substances List
Prepared / Revised By: Sunshine Makers, Inc., Regulatory Department.
This SDS has been revised in the following sections: Change to product identifier
DISCLAIMER: The information provided in this Safety Data Sheet is correct to the best of our knowledge, information and belief at the date of its publication. The
information given is designed only as guidance for safe handling, use, processing, storage, transportation, disposal and release and is not to be considered a warranty
or quality specification. The information relates only to the specific material designated and may not be valid for such material used in combination with any other
materials or in any process, unless specified in the text.

Page 5 of 5