CIRCUITS 304-EA5 & 304-EA6

COMPRISE BULK CABLE P/N 143-2452

304-EA5 WH-10 1 Electrical Schematic Symbols And Definitions
FF-C3
304-EA6 DK GY-10 2 RENR2253-02
CONN8A UPPER STARTER A UPPER STARTER CB1 FF-C1 EA-C4
3T3043 SMMS2
9F3099
SMMS1CB
1346296
CONN5A
8N1532
CONN5B
8N1533 G S MAY 2003
2 3 1 1 1
2 F701-FF1 TN-18 3 304-FF3 TN-10 304-FF5 TN-10 2 2 304-EA5 WH-10 1 MTR BAT
F701-FF1 TN-18 304-FF4 TN-10 32A 2 3 3
18 E799-FF2 TN-18 E799-FF2 TN-18 4 4 4 T
4 5 5 MOTOR STARTER 1A
1
304-FF6 TN-10 6
7
6
7
304-EA6 DK GY-10 2 7C0526
Pressure Temperature Level Flow Circuit Breaker
Symbol
GG-C3 CIRCUITS 304-M1 & 304-M2 Symbol Symbol Symbol Symbol
CONN8A COMPRISE BULK CABLE P/N 143-2452
3T3043
304-M1 WH-10 1
2 F701-GG11 TN-18 304-M2 DK GY-10 2
UPPER STARTER UPPER STARTER CB1 GG-C1 M-C1
18 E799-GG12 TN-18 SMMS1 SMMS1CB CONN5A CONN5B G S
9F3099 1346296 8N1532 8N1533
2 3 1 1 1
3 304-GG5 TN-10 304-GG1 TN-10 2 2 304-M1 WH-10 1 MTR BAT Normally open switch that will close with an increase of a specific condition (temp-press-etc.).
H-C1 AA-C1 32A 3 3
CABLE PDBOX A CONN8B CONN8A 4 2 4 4 The circle indicates that the component has screw terminals and a wire can be disconnected from it.
3T3044 3T3043 4 5 5 MOTOR STARTER 1
1 1 1 6 6 7C0526

E799-GG10 TN-18
304-GG6 TN-10 304-GG2 TN-10 304-M2 DK GY-10 2

F701-GG9 TN-18
F701-H2 143-2453 2 2 F701-EE3 TN-18 7 7
998-H3 143-2453 3 3 998-HH2 TN-18 CIRCUITS 304-N1 & 304-N2 Normally closed switch that will open with an increase of a specific condition.
SPARE-H4 143-2453 4 4 COMPRISE BULK CABLE P/N 143-2452
F718-H5 143-2453 5 5 F718-HH3 TN-18
LOWER STARTER LOWER STARTER CB2 GG-C2 N-C1 314-N1 WH-10 1 No circle indicates that the wire cannot be disconnected from the component.
SPARE-H6 143-2453 6 6 SMMS2CB CONN3A CONN3B 314-N2 DK GY-10 2
7 7 SMMS2 1346296 8N1532 8N1533
9F3099
SPARE-H8 143-2453 8 8 3 1 1 1
9 9 2 2 2 G S This indicates that the component has a wire connected to it that is connected to ground.
3 314-GG7 TN-10 314-GG3 TN-10 314-N1 WH-10 1
SPARE-H10 143-2453 10 10 3 3
11 11 4 32A 2 4 4 MTR BAT
F708-H12 143-2453 12 12 F708-AR5 TN-18 4 314-GG8 TN-10 5 5
13 13 1 6 6
314-GG4 TN-10 314-N2 DK GY-10 2
F700-H14 143-2453 14 14 F700-AR7 TN-18 7 7 MOTOR STARTER 2
SPARE-H15 143-2453 15 15 8N3896
F705-H16
SPARE-H17
143-2453
143-2453
16
17
16
17
F705-AL1 TN-18
AIR START RELAY
EE-C1
CONN 5A AU-C1 This indicates that the component does not have a wire connected to ground. It is grounded by
CONN5B
E799-H18 143-2453 18 18 E799-EE4 TN-18 ASF
9F3099
8N1532 8N1533 being fastened to the machine.
19 19 1 1
20 JUMPER WIRE TO BE 2
20 REMOVED WHEN INSTALLING AIR SHUT OFF WIRING 3 2 2
SPARE-H21 143-2453 21 21 F701-EE3 TN-18 3 3 AIR STARTER
H401-H23 143-2453 23 23 H401-JJ5 TN-18 E799-EE4 TN-18 4 4 AU-C2 SOLENOID
H401-H25 143-2453 25 25 4 5 5 7N9737 5N8980
H401-JJ6 TN-18 1 304-EE1 TN-14 304-AU1 143-2451 AIR START
103-H22
229-H24
143-2450
143-2450
22
24
22
24
103-AA1 TN-8
229-AA2 TN-8
304-EE5 TN-14
A290-EE2 TN-14
6
7
6
7 A290-AU2 143-2451
1
2
1 BK
2 BK
Reed Switch - A switch whose contacts are controlled by a magnet. A magnet closes the
contacts of a normally open reed switch; it opens the contacts of a normally closed reed switch.
B
X
BO U-C1 CC-C1
PD CONN7B CONN7
E

A290-EE2 TN-14
BL 3T3044 3T3043 CIRCUITS C465-P1 & A268-P4
CA

304-EE5 TN-14
1 1 ENGINE COMPRISE BULK CABLE P/N 143-2452
2 2 HH-C1 P-C1
3 3
CONN4A
3T3043
CONN4B
3T3044 Sender - A component that is used with a temperature or pressure gauge. The sender measures

3512B & 3516B Engines With Premium

4 4 C465-HH1 TN-10 1 1 C465-P1 WH-10 1 the temperature or pressure. Its resistance changes to give an indication to the gauge of the
16 INDEPENDENT SHUTDOWN DRIVE (-)
15 INDEPENDENT SHUTDOWN DRIVE (+)

5 5 2 2

16 PRELUBE PUMP RELAY DRIVE (-)

6 6 3 3 T temperature or pressure.

14 AIR SHUTOFF RELAY DRIVE (-)

12 AIR SHUTOFF RELAY DRIVE (+)
35 SWITCHED BATTERY POWER (-)
34 SWITCHED BATTERY POWER (+)

7 7 CB5 4 4 MOTOR
27 EMS II BATTERY POWER (-)
26 EMS II BATTERY POWER (+)

8 8 CB2 CB1 CB3 CB4 AIR 1 2 CB7 5 5 PRELUBE MOTOR AS

ALTERNATOR INPUT ETHER PANEL SHUT OFF PRELUBE
29 PRCM BATTERY POWER (-)
28 PRCM BATTERY POWER (+)

22 LOCAL CAT LINK (SHLD)

19 GLOBAL CAT LINK (SHLD)

Wiring Harness For Marine Auxilary

9 9 6 6 3T7583
25 SPEED POTENTIOMETER 3
24 SPEED POTENTIOMETER 2
23 SPEED POTENTIOMETER 1

12 SHUTDOWN NOTIFY (COM)

18 STARTER SOL DRIVE (-)

2 STARTER SOL DRIVE (+)

6A
CIRCUIT CIRCUIT CIRCUIT CIRCUIT CIRCUIT CIRCUIT
14 SHUTDOWN NOTIFY (NO)
13 SHUTDOWN NOTIFY (NC)

5 PRELUBE PRESS SWITCH

3 PRELUBE PRESS SWITCH
10 10 BREAKER BREAKER BREAKER BREAKER BREAKER BREAKER 7 7
18 GLOBAL CAT LINK (+)
17 GLOBAL CAT LINK (-)

11
21 LOCAL CAT LINK (+)
20 LOCAL CAT LINK (-)

11 1319134 1319122 1336456 1319123 1336454 3 4 1319140 998-HH2 TN-18 8 8 998-P2 WH-18 1 A268-P4 DK GY-10 2
KEY SWITCH SIGNAL

DIGITAL REFERENCE

24 BATTERY POWER (-)

22 BATTERY POWER (+)

12
KEY SWITCH POWER

12 (+) DOUBLE-POLE-BUS 9 9 Relay (Magnetic Switch) - A relay is an electrical component that is activated by electricity.
10 START/RUN/STOP1

START/RUN/STOP2

13 13 (-) 1319124 F718-HH3 TN-18 10 10 F718-P3 DK GY-18 2

F705-AL1 TN-18
14 It has a coil that makes an electromagnet when current flows through it. The electromagnet can
Power Electrical System
14 CB6 11 11
SHUTDOWN 'D'
SHUTDOWN 'C'

3 4 3 4 3 4 3 4 3 4 3 4 CIRCUITS 998-P2 & F718-P3

15 15 AIR START 12 12 COMPRISE BULK CABLE P/N 143-2456

63A

63A

20A

40A

32A

40A
16 16 CIRCUIT 13 13 open or close the switch part of the relay.
THROTTLE

BREAKER PRELUBE PRESSURE SWITCH

17 17 1 2 1 2 1 2 1 2 1 2 1319136 1 2 14 14 3N1400

C465-HH1 TN-10
18 18 15 15
109-U1 TN-6 19 19 16 16 1 2
109-CC1 TN-6 998-P2 WH-18 1

186-MM1 TN-8
A286-NN1 TN-8

115-AT2 TN-18
115-AT1 TN-18
A288-JJ4 TN-18
A288-JJ2 TN-18
20

168-AJ1 TN-10
A291-U2 TN-6 20 A291-CC2 TN-6 17 17
CONN9B
8N1518
CONN14B
3T3412

H-C2
L-C1

F700-AR7 TN-18
F708-AR5 TN-18
21 21 18 18 Solenoid - A solenoid is an electrical component that is activated by electricity. It has a coil that
37
36

33
32
31
30

25
23
21
20
19
17
15
13
11
10
11

9
8
7
6
4

1
22
Serial #:
9
8
7
6
5
4
3
2
1

22 101-LL1 TN-6 19 19 F718-P3 DK GY-18 2

ALT
23
24
23
24
229-LL2 TN-6 20
21
20
21
makes an electromagnet when current flows through it. The electromagnet can open or close
a valve or move a piece of metal that can do work.
143-2457
143-2457
143-2457
143-2457
143-2457
143-2457
143-2457
143-2457
143-2457
143-2457
143-2457
143-2457
143-2457
143-2457
143-2457
143-2454
143-2454
143-2454
143-2454
143-2454
143-2454
143-2457
143-2457
143-2457
143-2457
143-2457
143-2457
143-2457
143-2457
143-2457
143-2457
143-2457
143-2457
143-2457
143-2457
143-2457
143-2457

143-2453
143-2450
143-2453
143-2450
143-2453

143-2453
143-2453
143-2453
143-2453
143-2453
143-2453
143-2453
143-2453
143-2453
143-2453
143-2453
143-2453
143-2453
+ R 25 25 22 22
-
A268-HH4 TN-10 A268-HH4 TN-10
23
24
23
24 A268-P4 DK GY-10 2
8EM279-UP
ALTERNATOR 25 25
101-AM1 TN-18 PRELUBE SWITCH 9AN126-UP
103-L9
040-L8
060-L7
388-L6
998-L5

998-H3
183-L34

185-L28
201-L27
150-L26
090-L25
080-L24
070-L23
893-L21
892-L20
229-L19

030-L14
020-L13
010-L12
050-L10

F719-L4
F715-L3

229-H24
103-H22

F718-H5

F701-H2
A283-L35

A285-L29

A287-L22

J981-L18
J982-L17
P972-L16
P971-L15

SPARE-L2
SPARE-L1

H401-H25
H401-H23

E799-H18
F705-H16
F700-H14
F708-H12

SPARE-H8
SPARE-H6
SPARE-H4

9X8124
SPARE-L37
SPARE-L36

SPARE-L33
SPARE-L32
SPARE-L31
SPARE-L30

SPARE-L11

SPARE-H21

SPARE-H17
SPARE-H15

SPARE-H10

104-AN1 TN-18 86 85 2
ENGINE
30
87
118-AK1 TN-18
A268-AP1 TN-18
3
3WS1-UP Harness And Wire Symbols
87A 4
3XS1-UP

101-AM1 TN-18
1
PRELUBE RELAY * Harness identification letter(s) and a
9Y2921 Harness identification code

186-MM1 TN-8

104-AN1 TN-18

F700-AR6 TN-18

F708-AR4 TN-18
LL-C1
1PW1-UP This example indicates serializing code. The "C" stands for

103-AA1 TN-8
CONN1 86 85 168-AJ1 TN-10
8N1517 CIRCUITS 115-R1 & A288-R2
1 87 COMPRISE BULK CABLE P/N 230-3532 wire 135 in harness "AG". connector and the number indicates
30 Wire, Cable, or Harness
2
3
4
87A
JJ-C1
CONN2A
R-C1
CONN2B
AIR SHUT-OFF LH
SOLENOID
2FW1-UP Assembly Identification
which connector in the harness.
5 AIR SHUT OFF 3T0204 3T0203 2304073
RELAY 2 * Part Number For
6 9Y2921 1 1 1 BK * L-C12*
AG-C4*
395-JJ1 TN-18 395-JJ1 TN-18 115-R1 WH-18 1 115-R1 WH-18 1
7 + A288-JJ2 TN-18 2 2 A288-R2 DK GY-18 2 A288-R2 DK GY-18 2 2 BK C-C4 AG-C3 Connector Assembly
8
9 TERMINAL 1 394-JJ3 TN-18 394-JJ3 TN-18 3
4
3
4
115-R3 WH-18 1 130-6795 130-6795 111-7898 3E-5179
A288-JJ4 TN-18 A288-R4 DK GY-18 2

229-LL2 TN-6
1319127

101-LL1 TN-6
10 H401-JJ5 TN-18 5 5 H401-R5 TN-18
11 6 6 AIR SHUT-OFF RH 1 325-A135 PK-14
12 86 85 7 7
H401-R6
H401-R7
TN-18
TN-18 SOLENOID 325-A135 PK-14
2304073

F700-AR2 TN-18
13 87 H401-JJ6 TN-18 8 8 H401-R8 TN-18
14 9 9 115-R3 WH-18 1 1 BK

A286-NN1 TN-8
30
15
87A
10 10 A288-R4 DK GY-18 2 2 BK Socket Wire

F708-AR1 TN-18
16 11 11 Pin Wire Receptacle Fuse

229-AA2 TN-8
17 AIR SHUTOFF 12 12
18 RELAY 1
9Y2921 13 13 CIRCUITS 115-R3 & A288-R4 Color Gauge
19 14 14 COMPRISE BULK CABLE P/N 230-3532
20 15 15
21 TERMINAL 2
1319127
16 16 Single Wire Ground Plug
22 17 17 AIR SHUT OFF LH
23 18 18 SWITCH Connector Circuit Connection 2 200-L32 BK-14

1
2
SHOT 2.4 SEC
24 A268-AP1 TN-18 AR-C1 19 19 1 2 R-C2
- Number

RELAY-ONE
25 7N7782 20 20 H401-R5 TN-18 2277483
F700-AR2 TN-18
F708-AR1 TN-18
3
2
3
2
WH
RD H401-R6 TN-18
Identification
A288-AR3 TN-18 A288-AR3 TN-18 1 1 BK
AIR SHUT OFF TIMER AIR SHUT OFF RH
Pin or Socket 105-9344
9X3207 SWITCH Number

1
2
POWER DISTRIBUTION BOX 1 2 R-C3
H401-R7 TN-18 2277483 Typical representation of Component
H401-R8 TN-18 1 a Deutsch connector. The Typical representation of a Part Number
plug contains all sockets 1 Sure-Seal connector. The plug
2 and the receptacle contains 2 and receptacle contain

143-2454
143-2454
143-2454
143-2454
143-2454
143-2454
143-2457
143-2457
143-2457
143-2457
143-2457
143-2457
143-2457
143-2457
143-2457
143-2457
143-2457
143-2457
143-2457
143-2457
143-2457
143-2457
143-2457
143-2457
143-2457
143-2457
143-2457
143-2457
143-2457
143-2457
143-2457
143-2457
143-2457
143-2457
143-2457
143-2457
143-2457
all pins. both pins and sockets.
© 2003 Caterpillar Printed in U.S.A.

SPARE-L37
SPARE-L36

SPARE-L33
SPARE-L32
SPARE-L31
SPARE-L30

SPARE-L11
A287-L22

J981-L18
J982-L17

A283-L35

A285-L29

P972-L16
P971-L15

SPARE-L2
SPARE-L1
893-L21
892-L20
All Rights Reserved
229-L19

183-L34

185-L28
201-L27
150-L26
090-L25
080-L24
070-L23

030-L14
020-L13
010-L12
050-L10

F719-L4
F715-L3
103-L9
040-L8
060-L7
388-L6
998-L5
CABLE INSTR B CABLE INSTR A
CONN15B
8N1514
L-C2

22
21
20
19
18
17
37
36
35
34
33
32
31
30
29
28
27
26
25
24
23
16
15
14
13
12
10
11
9
8
7
6
5
4
3
2
1
CIRCUITS 892-WH AND 893-WH MUST BE CIRCUITS J981-WH AND J982-WH MUST BE
TWISTED TOGETHER AND KEPT AS SHORT AS TWISTED TOGETHER AND KEPT AS SHORT AS
POSSIBLE. A287 IS THE SHIELD FOR 892 & 893. POSSIBLE. 229 IS THE SHIELD FOR J981 & J982.

112-2974 112-2975 118-8582

GAGE 1 GAGE 2 GAGE 3
VOLTAGE OIL FILTER DIFF BOOST CIRCUITS 892-TN AND 893-TN MUST BE
OIL PRES FUEL FILTER DIFF A/C TEMP TWISTED TOGETHER AND KEPT AS SHORT AS
COOLANT TEMP EXHAUST TEMP ATTACHMENT 1 POSSIBLE.
FUEL PRES INLET RESTRICTION ATTACHMENT 2 CIRCUITS J981-TN AND J982-TN MUST BE ECM BOX HOSE & ADAPTER LOCATION
TWISTED TOGETHER AND KEPT AS SHORT AS
POSSIBLE. CONNECTOR
CONN15A
1552264

1552264

1552264

8N1513
V-C1
V-C5

V-C6

V-C7

22
21
20
19
18
17
37
36
35
34
33
32
31
30
29
28
27
26
25
24
23
16
15
14
13
12
11
10
1
2
3
4
5
6
7
8
1
2
3
4
5
6
7
8

1
2
3
4
5
6
7
8

9
8
7
6
5
4
3
2
1
MANIFOLD
TN-18
TN-18
TN-18
TN-18
TN-18

TN-18
TN-18
TN-18
TN-18
TN-18
TN-18

TN-18
TN-18
TN-18
TN-18
TN-18
201-V108 TN-18

TN-18
TN-18
TN-18
TN-18

TN-16
TN-16

TN-16
TN-16
TN-16
TN-16
TN-18
TN-18
TN-18
TN-18
TN-18
TN-18
TN-18
TN-18
TN-18
TN-18
TN-18
TN-18
TN-18
TN-18
TN-18
TN-18
ENGINE
049-V52
201-V84
053-V94
052-V95
051-V96

049-V97
201-V98
053-V99
052-V100
051-V101
201-V102

049-V103
201-V104
053-V105
052-V106
051-V107

103-V9
040-V8
060-V7
388-V6
998-V5
893-V21
892-V20

183-V37

185-V28
201-V27
150-V26
090-V25
080-V24
070-V23

030-V14
020-V13
010-V12
050-V10

F719-V4
F715-V3
J981-V18
J982-V17

A283-V38

A285-V29

P972-V22
P971-V11

CUSTOMER
DATA
CONNECTOR
VX-C1 V-C3
CUSTOMER INTALLED ATTACHMENTS CONN16B CONN16A
8T9834 9X1343
A285-V29 TN-16
185-V28 TN-16
TN-16
TN-18
TN-18
TN-18
TN-18
TN-18
TN-18
TN-18
TN-18
TN-18
TN-18
TN-18
TN-18
TN-18
TN-18
TN-18
TN-18
TN-18
TN-16
TN-16

TN-18
TN-18
TN-18

150-V26 TN-16

1 1
2 2 Filtered Oil Pressure Sensor Coolant Temp Sensor Boost
3 3 RH Turbo Inlet Pressure Sensor
4 4
J981-V18
J982-V17

F719-V4
F715-V3
040-V8
060-V7
388-V6

103-V9

998-V5
090-V25
080-V24
070-V23

030-V14
020-V13
010-V12
050-V10

183-V37
201-V27
893-V21
892-V20
P972-V22
P971-V11

5 5
Unfiltered Oil Pressure Sensor
A283-V38

6 6 Ambient
TWISTED TOGETHER AND KEPT AS SHORT
CIRCUITS 892-TN AND 893-TN MUST BE

7 INDEPENDENT SHUTDOWN DRIVE (+) 7 P971-V11 TN-18

8 INDEPENDENT SHUTDOWN DRIVE (-) 8 P972-V22 TN-18
9 9 F411-V79 TN-18
10 10 022-V19 TN-18
11 LOCAL CAT LINK (-) 11 892-V41 TN-18 D936-V52 TN-18

RENR2253-02
12 LOCAL CAT LINK (+) 12 893-V42 TN-18 H456-V51 TN-18
13 SHUTDOWN NOTIFY (COM) 13 010-V12 TN-18 C464-V49 TN-18 026-V88 TN-18 1 2 201-V109 TN-18
14 GLOBAL CAT LINK (+) 14 J981-V18 TN-18 024-V43 TN-18
15
16
SHUTDOWN NOTIFY (NC)
EMS SWITCH 4 (CHARGER FAULT)
15
16
020-V13
022-V19
TN-18
TN-18
P971-V11
P972-V22
TN-18
TN-18
V-C9
ALARM SWITCH
AFTERCOOLER TEMP SENSOR
9W0073
17
18
SHUTDOWN NOTIFY (NO) 17
18
030-V14 TN-18 103-V9 TN-18 WITH SCAC APPLICATION
AS POSSIBLE.

EMSII SWITCH 9 (FUEL LEVEL) 024-V43 TN-18 070-V23 TN-18

19 DIGITAL REFERENCE 19 998-V44 TN-18 010-V12 TN-18 3 2
20 DIGITAL REFERENCE 20 998-V45 TN-18 020-V13 TN-18 027-V85 TN-18 1 201-V113 TN-18
Note: Requires 21 DIGITAL REFERENCE 21 998-V46 TN-18 030-V14 TN-18 027-V115 TN-18 201-V110 TN-18
Adaptor 9X-3271 22 GLOBAL CAT LINK (-) 22 J982-V17 TN-18 J981-V18 TN-18 SERVICE
23 23 J982-V17 TN-18 SWITCH
Seal 6V-5049 24 24 8N0694
050-V10 TN-18 NOTE B
AIR INLET 25 EMSII 8 (VOLT SUPPLY) 25 C464-V49 TN-18 060-V7 TN-18
TEMPERATURE 26 26 040-V8 TN-18

30 Page, EAR
1952150 27 27 4
H456-VX1 TN-18 EMS SENSOR 7(AIR INLET TEMP)(SW 17 INPUT) H456-V51 TN-18 F715-V3 TN-18 028-V89 TN-18 5
1K 1 H456-VX1 TN-18 28 EMS SWITCH 6(COOLANT LEVEL) 28 D936-V52 TN-18 F719-V4 TN-18 6
T 2 201-VX3 DK GY-18 29 START/RUN/STOP1 29 050-V10 TN-18 388-V6 TN-18 028-V116 TN-18 1 2
30 START/RUN/STOP2 30 060-V7 TN-18 080-V24 TN-18 3 201-V111 TN-18
31 KEY SWITCH SIGNAL 31 040-V8 TN-18 090-V25 TN-18 027-V115 TN-18
32 KEY SWITCH POWER 32 103-V9 TN-18 998-V46 TN-18 MODE CLEAR V-C4
CIRCUITS H456 AND 201 ARE 33 SHUTDOWN 'C' 33 F715-V3 TN-18 893-V42 TN-18 SWITCH 8T9834
7N8008
TO BE CREATED BY USING
CABLE #143-2456 F411-VX2 TN-18
34
35
SHUTDOWN 'D'
EMS SENSOR 6(ENGINE OIL TEMP)(SW 16)
34
35
F719-V4
F411-V79
TN-18
TN-18
892-V41
998-V44
TN-18
TN-18
NOTE B 150-V26
C464-V49
TN-16
TN-18
150-V26 TN-16
201-V74 TN-16
1
2
BATTERY (+)
BATTERY (-)
LH Turbo Inlet Pressure Sensor
CIRCUITS J981-TN AND J982-TN MUST BE

36 REMOTE THROTTLE 36 388-V6 TN-18 F411-V79 TN-18 3 HARNESS CODE 1

TWISTED TOGETHER AND KEPT AS SHORT

37 37 3 2 4
201-V27 TN-16

SPEED POTENTIOMETER 3 090-V25 TN-18 029-V83 TN-18 201-V112 TN-18 022-V19 TN-18 025-V76 TN-18 ACTION ALARM
38 SPEED POTENTIOMETER 2 38 080-V24 TN-18 024-V43 TN-18 893-V77 TN-18 5 LOCAL CAT LINK (+)
39 SPEED POTENTIOMETER 1 39 070-V23 TN-18 998-V45 TN-18 RH LH SWITCH D936-V52 TN-18 201-V78 TN-18 6 HARNESS CODE 5
40 40 8D2676
NOTE B H456-V51 TN-18 7 SENSOR 1(SW 11) Ambient Pressure Sensor
VX-C2 V-C2 029-V83 TN-18 8 SENSOR 5(SW 15)
CONN17B CONN17A 028-V89 TN-18 9 SWITCH 10(FUEL)
7X6222 9X0145 027-V85 TN-18 F411-V79 TN-18 10 SENSOR 6(ENGINE OIL TEMP)(SW 16)
1 1 185-V28 TN-16 026-V88 TN-18 11 SWITCH 7
2 2 A285-V29 TN-16 12 HARNESS CODE 2
3 3 HORN 201-V114 TN-18 13 ACTION LAMP
4 4 1239694 025-V76 TN-18 025-V76 TN-18 892-V80 TN-18 14 LOCAL CAT LINK (-)
AS POSSIBLE.

5 SWITCHED BATTERY POWER (+) 5 183-V34 TN-16 051-V81 TN-18 15 MODULE LOAD
6 PRCM BATTERY POWER (+) 6 185-V28 TN-16 201-V82 TN-18 16 HARNESS CODE 4
7 7 17 SENSOR 2(SW 12)
8
9
8
9
201-V15 TN-18 024-V43 TN-18
029-V83 TN-18
18
19
SWITCH 9(FUEL LEVEL)
SWITCH 1 Turbo Outlet Pressure Sensor
10 10 022-V19 TN-18 20 SWITCH 4 (CHARGER FAULT)
Note: Requires 11 11 21 SWITCH 8
Adaptor 9X-3271 12 12 201-V15 TN-18 22 HARNESS CODE 3

AS POSSIBLE.
TWISTED TOGETHER AND KEPT AS SHORT
CIRCUITS 892-TN AND 893-TN MUST BE
Seal 6V-5049
13 13 201-V78 TN-18 027-V85 TN-18 23 SERVICE
ENGINE OIL 14 14 201-V31 TN-16 201-V74 TN-16 C464-V49 TN-18 24 + 8 VOLT OUT
TEMPERATURE 15 15 201-V33 TN-16 201-V82 TN-18 053-V87 TN-18 25 MODULE CLOCK
195-2150 16 16 201-V16 TN-18 26 TRANS SPEED IN
1K 1 F411-VX2 TN-18 17 EMS II POWER (-) 17 201-V30 TN-16 27 SENSOR 4(SW 14)
2 201-VX4 DK GY-18 18 EMS II POWER (-) 18 201-V31 TN-16 892-V80 TN-18 H456-V51 TN-18 28 SENSOR 7(AIR INLET TEMP)(SW 17)
T
201-VX3 DK GY-18 19
20
EMS II POWER (-)
EMS II POWER (-)
19
20
201-V32
201-V33
TN-16
TN-16
201-V32
201-V30
TN-16
TN-16
893-V77 TN-18 026-V88 TN-18 29
30
SWITCH 2
ALTERNATOR 'R' 3512B FRONT VIEW
201-VX4 DK GY-18 21 EMS II POWER (-) 21 201-V36 TN-16 201-V36 TN-16 201-V16 TN-18 31 HARNESS CODE 0
CIRCUITS F411 AND 201 ARE 22 PRCM BATTERY POWER (-) 22 A285-V29 TN-16 183-V34 TN-16 D936-V52 TN-18 32 COOLANT LEVEL(SWITCH 6)
TO BE CREATED BY USING 23 SWITCHED POWER (-) 23 A283-V35 TN-16 A283-V35 TN-16 028-V89 TN-18 33 CLEAR
TN-16
TN-16
201-V104 TN-18
TN-18
201-V114 TN-18
TN-16
TN-18
TN-18
TN-18
201-V109 TN-18
201-V113 TN-18
201-V112 TN-18
TN-18
TN-18
TN-18
TN-18
TN-18
049-V103 TN-18
053-V105 TN-18
052-V106 TN-18
051-V107 TN-18
TN-18
TN-18
TN-18
TN-18
TN-18
183-V37 TN-16

A283-V38 TN-16

CABLE #143-2456 24 24 053-V87 TN-18 049-V90 TN-18 34 (+) V CLUSTER

051-V81 TN-18 052-V91 TN-18 35 MODULE DATA
CUSTOMER 049-V90 TN-18 36 ENGINE SPEED IN
RH Exhaust Temperature Sensor
201-V33
201-V31

201-V98

201-V74
201-V78
201-V16
201-V82

998-V45
052-V95
053-V94
049-V52
051-V96

892-V20
893-V21
893-V77
892-V80

052-V91 TN-18 37 SENSOR 3(SWITCH 13)

998-V5

POWER 38 SENSOR 8(SWITCH 18)

CONNECTOR V-C8 TC-C17 39 SWITCH 3
1698668 3E3363 40 SWITCH 5
183-V127 TN-16 1 183-TC5 TN-16
A283-V128 TN-16 2 A283-TC6 TN-16 EMS II
CONNECTOR
TN-18
TN-18
TN-18
TN-16
TN-18
TN-18

TN-18
TN-18
TN-18
TN-18

TN-18
TN-18

TN-18
TN-18

TN-18
TN-18

TN-18
TN-18

TN-18
TN-18

TN-18
TN-18

TN-18
TN-18

TN-16

TN-16
201-V31 TN-16
201-V130 TN-16

201-V33 TN-16
201-V98 TN-18

TC-C18
3E7990
A283-TC6 TN-16
183-TC5 TN-16
201-V104

053-V105

052-V106

051-V107

049-V103
201-V112
201-V113

201-V109

A283-V38
201-V114

183-V37
201-V15
201-V78
201-V82
201-V74

201-V16

053-V94

052-V95

051-V96

049-V52

998-V45

892-V80
892-V20

893-V77
893-V21

RS485A-RED-TC 134-6258 1 1
998-V5

RS485-SHIELD-TC 134-6258 2 2
3 3
A283-TC2 TN-16 4 4
OUT-1-COM-TC6 TN-18 5 5
OUT-2-COM-TC7 TN-18 6 6
OUT-2-NO-TC8 TN-18 7 7
OUT-1-NO-TC9 TN-18 8 8
A283-V128 TN-16
TN-16

201-V203 TN-16

183-V127 TN-16
201-V30 TN-16
201-V27 TN-16
201-V84 TN-18

TN-16
TN-16
TN-18

201-V108 TN-18

053-V99 TN-18
053-V87 TN-18

052-V100 TN-18
052-V91 TN-18

051-V81 TN-18
051-V101 TN-18

049-V90 TN-18
049-V97 TN-18

998-V44 TN-18
998-V46 TN-18

892-V41 TN-18

893-V42 TN-18

183-V34 TN-16

A283-V35 TN-16

183-TC4 TN-16 9 9
10 10
11 11
183-TC4 TN-16
183-TC3 TN-16

A283-TC2 TN-16
A283-TC1 TN-16

RS485B-BLK-TC 134-6258 12 12
201-V36
201-V32
201-V102
201-V202

EXHAUST EXHAUST EXHAUST EXHAUST EXHAUST EXHAUST EXHAUST EXHAUST

TC-C16 C-C18 PORT #1 PORT #3 PORT #5 PORT #7 PORT #9 PORT #11 PORT #13 PORT #15
155-2252 155-2252

+ - + - + - + - + - + - + - + -
1
2

1
2

1
2

1
2

1
2

1
2

1
2

1
2

E-C1 E-C3 E-C5 E-C7 E-C9 E-C11 E-C13 E-C15

155-2269 155-2269 155-2269 155-2269 155-2269 155-2269 155-2269 155-2269
116-2652
116-2652

116-2652
116-2652

116-2652
116-2652

116-2652
116-2652

116-2652
116-2652

116-2652
116-2652

116-2652
116-2652

116-2652
116-2652
TN-16
183-V127 TN-16
201-V27 TN-16

201-V84 TN-18
201-V108 TN-18
201-V102 TN-18
201-V32 TN-16
201-V30 TN-16
201-V36 TN-16

053-V87 TN-18
052-V91 TN-18
051-V81 TN-18
049-V90 TN-18
053-V99 TN-18
052-V100 TN-18
051-V101 TN-18
049-V97 TN-18
998-V44 TN-18
998-V46 TN-18
892-V41 TN-18
893-V42 TN-18
183-V34 TN-16
A283-V35 TN-16

TN-16
A283-TC1 TN-16
TN-16
A283-TC2 TN-16
A283-V128

1-YEL
1-RED

3-YEL
3-RED

5-YEL
5-RED

11-YEL
11-RED
7-YEL

13-YEL
13-RED
7-RED

15-YEL
15-RED
9-YEL
9-RED
183-TC3

183-TC4

TC-C21 E-C17
9X1343 8T9834
1
TC1-YEL-RH
116-2652 1
2
TC1-RED-RH
116-2652 2
3
TC2-YEL-RH
116-2652 3
TC-C20 4
TC2-RED-RH
116-2652 4
9X1343 5
TC3-YEL-RH
116-2652 5
1 TC2-YEL-LH 116-2652 6
TC3-RED-RH
116-2652
7
TC4-YEL-RH
116-2652
6
7
Filtered Oil Pressure Sensor
2 TC2-RED-LH 116-2652
3 TC1-YEL-LH 116-2652 116-2652 8
TC4-RED-RH 8
4 TC1-RED-LH 116-2652 116-2652 9
TC5-YEL-RH 9
5
6
TC4-YEL-LH
TC4-RED-LH
116-2652
116-2652 116-2652
10
TC5-RED-RH
116-2652
11
TC6-YEL-RH
10
11 Filtered Fuel Pressure Sensor
7 TC3-YEL-LH 116-2652 116-2652 12
TC6-RED-RH 12
8 TC3-RED-LH 116-2652 116-2652 13
TC7-YEL-RH 13
9 TC6-YEL-LH 116-2652 116-2652 14
TC7-RED-RH 14
10 TC6-RED-LH 116-2652 116-2652 15
TC8-YEL-RH 15
11 TC5-YEL-LH 116-2652 116-2652 16
TC8-RED-RH 16
12 TC5-RED-LH 116-2652 116-2652 17
TC9-YEL-RH 17
13 TC8-YEL-LH
14 TC8-RED-LH
116-2652
116-2652
18
TC9-RED-RH
116-2652
19
TC10-YEL-RH
116-2652
18
19
Unfiltered Fuel Pressure Sensor
15 TC7-YEL-LH 116-2652 116-2652 20
TC10-RED-RH 20
16 TC7-RED-LH 116-2652 116-2652 21
TC11-YEL-RH 21
17 TC10-YEL-LH 116-2652 116-2652 22
TC11-RED-RH 22
RS485-SHIELD-TC 134-6258

134-6258
134-6258

18 TC10-RED-LH 116-2652 116-2652 23

TC12-YEL-RH 23
19 TC9-YEL-LH 116-2652 116-2652 24
TC12-RED-RH 24
TN-18
TN-18
TN-18
TN-18

TN-18
TN-18
TN-18
TN-18

TN-18
TN-18
TN-18
TN-18

TN-18
TN-18
TN-18
TN-18
TN-18
TN-18
TN-18
TN-18

20 TC9-RED-LH 116-2652 116-2652 25

TC13-YEL-RH 25
21 TC12-YEL-LH 116-2652 116-2652 26
TC13-RED-RH 26
22 TC12-RED-LH 116-2652 116-2652 27
TC14-YEL-RH 27
A283-TC1 TN-16

28
TC14-RED-RH
116-2652 28
183-TC3 TN-16

23 TC11-YEL-LH 116-2652
1-TC10
1-TC10
2-TC11
2-TC11

3-TC12
3-TC12
4-TC13
4-TC13

5-TC14
5-TC14
6-TC15
6-TC15

JUMPER 7-TC16
JUMPER 8-TC17
JUMPER 8-TC17
OUT-2-COM-TC7
JUMPER 7-TC16

OUT-1-COM-TC6

RS485A-RED-TC
RS485B-BLK-TC

29
TC15-YEL-RH
116-2652 29
OUT-2-NO-TC8
OUT-1-NO-TC9

24 TC11-RED-LH 116-2652
25 TC14-YEL-LH 116-2652 116-2652 30
TC15-RED-RH 30
26 TC14-RED-LH 116-2652 116-2652 31
TC16-YEL-RH 31
32
TC16-RED-RH
116-2652 32
JUMPER
JUMPER
JUMPER
JUMPER

JUMPER
JUMPER
JUMPER
JUMPER

JUMPER
JUMPER
JUMPER
JUMPER

27 TC13-YEL-LH 116-2652
28 TC13-RED-LH 116-2652 33 33
29 TC16-YEL-LH CONNECTOR PIN ASSIGNMENT REPRESENTS 34 34
116-2652 STANDARD RIGHT HAND SERVICE USING
30 TC16-RED-LH 116-2652 TC-C19 INTERNAL BOX HARNESS 195-5971
35 35
Unfiltered Fuel Pressure Sensor
116-2652
116-2652

116-2652
116-2652

116-2652
116-2652

116-2652
116-2652

10-YEL 116-2652
10-RED 116-2652

12-YEL 116-2652
12-RED 116-2652

14-YEL 116-2652
14-RED 116-2652

16-YEL 116-2652
16-RED 116-2652

31 TC15-YEL-LH 116-2652 160-7689 36 36

J1 37 37
12

32 TC15-RED-LH
11
13
14
16
17
18
19
20
21
22
23
24
25
26
27
28
29
30
31
32
33
34
35
36
37
38
39
40
41
42
43
44
45
46

49
50
51
52
53
54
55
56

59
60
61
62
63
64
65
66
67
68
69
70
15

57

116-2652
58
48
10

47
1
2
3
4
5
6
7
8
9

33 38 38
34 39 39
35 40 40
CONNECTOR PIN ASSIGNMENT REPRESENTS
Aftercooler Temperature Sensor
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
26
27
28
29
30
31
32
33
34
35
36
37
38
39
40
41
42
43
44
45
46
47
48
49
50
51
52
53
54
55
56
57
58
59
60
61
62
63
64
65
66
67
68
69
70

36
Crankcase Pressure Sensor
2-YEL
2-RED

4-YEL
4-RED

6-YEL
6-RED

8-YEL
8-RED
1
2
3
4
5
6
7
8
9

LEFT HAND SERVICE USING INTERNAL

37 BOX HARNESS 195-5972
NC (SENSE ROT.)
NC (SPARE INPUT)

38
+TC7 YEL
-TC7 RED
+TC8 YEL
-TC8 RED

SHIELD, RS485
NC
NC
+TC4 YEL
-TC4 RED

JUMPER
JUMPER
JUMPER
JUMPER
+TC15 YEL
-TC15 RED
+TC16 YEL
-TC16 RED
+TC5 YEL
-TC5 RED
+TC6 YEL
-TC6 RED

+TC9 YEL
-TC9 RED
+TC10 YEL
-TC10 RED

+TC11 YEL
-TC11 RED
+TC12 YEL
-TC12 RED

OUT 2 COM
OUT 2 N/O
OUT 1 N/O
OUT 1 COM

RS485A RED
RS485B BLK
NC
NC

NC
NC
NC
NC
+TC3 YEL
-TC3 RED
+TC13 YEL
-TC13 RED
+TC14 YEL
-TC14 RED

For JWAK Application

NC
NC
YEL
RED
YEL
RED

JUMPER
JUMPER
JUMPER
JUMPER

JUMPER
JUMPER
JUMPER
JUMPER

JUMPER
JUMPER
JUMPER
JUMPER
POWER + POS
POWER - NEG
NC

39 E-C2 E-C4 E-C6 E-C8 E-C10 E-C12 E-C14 E-C16

40 155-2269 155-2269 155-2269 155-2269 155-2269 155-2269 155-2269 155-2269
+TC1
-TC1
+TC2
-TC2

3512B FRONT VIEW 3512B RIGHT SIDE VIEW

1
2

1
2

1
2

1
2

1
2

1
2

1
2

1
2

TEMPERATURE SCANNER + - + - + - + - + - + - + - + -

INSTRUMENT PANEL BOX Duplex Filter Sensor Locations

EXHAUST EXHAUST EXHAUST EXHAUST EXHAUST EXHAUST EXHAUST EXHAUST
PORT #2 PORT #4 PORT #6 PORT #8 PORT #10 PORT #12 PORT #14 PORT #16

179-9001
 RENR2253-02
30 Page, BW, EAR

C
D
G
H

A
B
E
I

12
12

060-A175

103-A188
ECM BOX

103-A173 TN-18
040-A174 TN-18
050-A172 TN-18
TN-18

TN-18
103-A146 TN-18
103-A141 TN-18
103-A148 TN-18
998-A203 TN-18

103-A149 TN-18
10
12
13
14

17
18
19
20
15
22
23
24
25

8
9

3
4
5
OFF1 7
OFF2
OFF3

EMSSS
2 OFF-B
OFF-K
AUTO1
STOP1
AUTO2
STOP2
AUTO3
STOP3

AUTO-B
STOP-B
AUTO-K
STOP-K
START1
START2
START3

-INDEPENDENT SHUTDOWN RELAY

START-B
START-K

-AIR INLET TEMPERATURE SENSOR

1272331

-ENGINE OIL TEMPERATURE SENSOR

ROTARY SWITCH

1
6

16
11
21

11
F721-A60 TN-18
11

F717-A59 TN-18
F716-A56 TN-18
113-A64 TN-18
110-A16 TN-14 113-A147 TN-18
103-A145 TN-18
103-A144 TN-18 103-A143 TN-18

30
30

86
86

ESR
RELAY
103-A142 TN-18

9Y2921
E-STOP
ESLR
9Y2921
RELAY
(+)
A287-A186 TN-18 ELECTRIC SPEED

85
85
A-C1 103-A180 TN-8 32A F-C2 SENSOR

E-STOP LOCKOUT

87
87
CONN14A 8T8731 212-3426

1
87A
87A
229-A181 TN-8 (-) CABLE 1
3T3410
ESSS-F1 144-1104 A
INPUT BREAKER BK-18 ANALOG RET
37 INPUTCB ESS1-F2 144-1104 B
WH-18 SIGNAL

SOME EARLY ENGINES NOT EQUIPPED WITH COMPONENTS FOR:

36 1346296 ESS2-F18 144-1104 C
SWITCHED BATTERY POWER (-) 35 A283-A154 TN-16

103-A149
SWITCHED BATTERY POWER (+) 34 183-A155 TN-16 A287-A187 TN-18 RIGHT EXHAUST
33 050-A172 TN-18 F-C3 TEMP SENSOR
A-C10 F-C1
32 8T8731 212-3425
103-A173 TN-18 CONN13A CONN13B

103-A142
CABLE 2
31 8N1513 8N1514 C WH-18 SIGNAL

TN-18
040-A174 TN-18 (+)
F704-F5 143-2455
30 060-A175 TN-18 110-A16 TN-14 103-A131 TN-18 37 37 998-F4 143-2455 B BK-18 DIGITAL RET
16A

103-A139 TN-18
OR-18

1 1
PRCM BATTERY POWER (-) 29 36 36 A +V DIGITAL

103-A146 TN-18
113-A147 TN-18
A285-A156 TN-16 A287-A199 TN-14 A700-F3 143-2455

103-A138 TN-18
(-)

103-A65 TN-18
28 35 35

113-A102 TN-18
PRCM BATTERY POWER (+)

103-A148 TN-18
TN-18
185-A157 TN-16 A287-A200 TN-14
EMS II BATTERY POWER (-) 27 201-A158 TN-16 PANEL BREAKER 34 34
PANELCB LEFT EXHAUST
EMS II BATTERY POWER (+) 26 150-A159 TN-16 33 33 F-C4 TEMP SENSOR

2
6
8
1346297

103-A145
SPEED POTENTIOMETER 3 25 090-A106 TN-18 185-A157 TN-16 32 32 ESSS-F1 144-1104 8T8731 212-3425
CABLE 3

103-A140
WH-18

E-STOP
SPEED POTENTIOMETER 2 24 31 31 C SIGNAL

1096507

3
080-A105 TN-18 A285-A156 TN-16 ESSS-A8 CABLE A700-F3 143-2455 F703-F8 143-2455

1
5
7
SPEED POTENTIOMETER 1 23 070-A113 TN-18 201-A158 TN-16 ESS1-A10 CABLE 30 30 A700-F6 143-2455 998-F7 143-2455 B BK-18 DIGITAL RET
LOCAL CAT LINK (SHLD) 22 29 29 A OR-18 +V DIGITAL

TN-18
A287-A160 TN-18 150-A159 TN-16 ESS2-A16 CABLE 998-A1 TN-18 998-F22 143-2455 997-F11 143-2455 A700-F6 143-2455
LOCAL CAT LINK (+) 21 893-A161 TN-18 A283-A154 TN-16 997-A19 TN-18 28 28 997-F14 143-2455

1111324
1111324
1111323
1111323
TN-18

TO
LOCAL CAT LINK (-) 20 892-A162 TN-18 183-A155 TN-16 997-A20 TN-18 993-A3 TN-18 27 27 993-F16 143-2455 997-F17 143-2455 RIGHT TURBO INLET

PANEL
GLOBAL CAT LINK (SHLD) 19 A287-A163 TN-18 P972-A10 TN-18 997-A21 TN-18 993-A4 TN-18 26 26 993-F13 143-2455 996-F21 143-2455 F-C5 PRESSURE SENSOR

INSTRUMENT
GLOBAL CAT LINK (+) 18 J981-A164 TN-18 P971-A8 TN-18 993-A5 TN-18 993-A5 TN-18 25 25 993-F10 143-2455 8T8732 212-3422
CABLE 4

103-A133
103-A130
F708-A63
103-A139
17 24 24 C GN-18 SIGNAL

F708-A119
GLOBAL CAT LINK (-) J982-A165 TN-18 020-A169 TN-18 998-A1 TN-18 998-A6 TN-18 998-F7 143-2455 F714-F9 143-2455

10
INDEPENDENT SHUTDOWN DRIVE (-) 16 23 23 B YL-18 ANALOG RET
10

P972-A10 TN-18 030-A168 TN-18 998-A6 TN-18 998-A7 TN-18 998-F4 143-2455 993-F10 143-2455
INDEPENDENT SHUTDOWN DRIVE (+) 15 P971-A8 TN-18 010-A170 TN-18 998-A7 TN-18 ESSS-A8 CABLE 22 22 ESSS-F1 144-1104 997-F11 143-2455 A OR-18 +V ANALOG
SHUTDOWN NOTIFY (NO) 14 030-A168 TN-18 F719-A176 TN-18 993-A4 TN-18 999-A9 TN-18 21 21 999-F23 143-2455

A287-A186
TN-18
TN-18
TN-18
TN-18

POSSIBLE.
TN-18
SHUTDOWN NOTIFY (NC) 13 020-A169 TN-18 F715-A183 TN-18 993-A3 TN-18 ESS1-A10 CABLE 20 20 ESS1-F2 144-1104 ESS1-F2 144-1104 LEFT TURBO INLET
SHUTDOWN NOTIFY (COM) 12 010-A170 TN-18 J982-A165 TN-18 F795-A11 TN-18 19 19 E795-F15 143-2455 998-F4 143-2455 F-C6 PRESSURE SENSOR

POSSIBLE.
8T8732 212-3422

S2
11 18 18

113-A102 TN-18
J981-A164 TN-18 A746-A12 TN-18 F713-F12 143-2455 998-F7 143-2455 CABLE 5

30
(+) GN-18

86
START/RUN/STOP1 10 17 17 C SIGNAL

TN-18
050-A172 TN-18 892-A162 TN-18 10A 103-A18 TN-16 A700-A22 TN-18 F714-A13 TN-18 F714-F9 143-2455 993-F10 143-2455 F713-F12 143-2455
KEY SWITCH POWER 16 16 B YL-18 ANALOG RET
9 103-A173 TN-18 893-A161 TN-18 A285-A156 TN-16 A700-A23 TN-18 F703-A14 TN-18 F703-F8 143-2455 993-F13 143-2455 993-F13 143-2455

PRCM
(-)

PRCMR
OR-18

RELAY
8 15 15 A +V ANALOG

9Y2921
KEY SWITCH SIGNAL 040-A174 TN-18 F704-A15 TN-18 F704-F5 143-2455 993-F16 143-2455 997-F14 143-2455
PRCM BREAKER

85
START/RUN/STOP2 7 060-A175 TN-18 998-A177 TN-18 PRCMCB ESS2-A16 CABLE 14 14 ESS2-F18 144-1104 998-F22 143-2455

2
87

87A
DESIRED SPEED SIGNAL 6 F702-A109 TN-18 A287-A160 TN-18 1346306 13 13 CRANKCASE

1
PRIMARY DIGITAL REFERENCE 5 998-A177 TN-18 A287-A163 TN-18 12 12 F-C7 PRESSURE SENSOR
SHUTDOWN 'D' 4 F719-A176 TN-18 090-A106 TN-18 185-A157 TN-16 F703-A14 TN-18 11 11 8T8732 212-3422
CABLE 6
SHUTDOWN 'C' 3 F715-A183 TN-18 070-A113 TN-18 F704-A15 TN-18 10 10 E795-F15 143-2455 C GN-18 SIGNAL
2 9 B YL-18 DIGITAL RET
080-A105 TN-18 F714-A13 TN-18 9 993-F16 143-2455
1 8 8 A OR-18 +V DIGITAL

CIRCUITS 892-WH AND 893-WH MUST BE

F702-A109 TN-18 A746-A12 TN-18 996-A17 TN-18 996-F21 143-2455 ESS2-F18 144-1104 997-F17 143-2455

30
(+)

86
10A 103-A103 TN-16 7 7 F704-F5 143-2455
A-C2

TWISTED TOGETHER AND KEPT AS SHORT AS

CONN9A 201-A158 TN-16 999-A9 TN-18 997-A19 TN-18 6 6 997-F17 143-2455 F703-F8 143-2455 PRIMARY SPEED
(-)

RELAY

9Y2921
8N1517 5 5 F-C9 TIMING SENSOR

EMS II

CIRCUITS J981-WH AND J982-WH MUST BE

H401-A201 TN-18 F795-A11 TN-18 997-A20 TN-18 997-F14 143-2455 F714-F9 143-2455

EMS IIR
EMS II BREAKER

TWISTED TOGETHER AND KEPT AS SHORT AS

8T8732 212-0848

85
25 H401-A201 TN-18 229-A181 TN-8 EMS IICB 996-A17 TN-18 997-A21 TN-18 4 4 997-F11 143-2455 F713-F12 143-2455 CABLE 7

87

87A
BATTERY POWER (-) 24 229-A181 TN-8 103-A180 TN-8 1346306 A700-A22 TN-18 3 3 A700-F6 143-2455 E795-F15 143-2455 999-F23 143-2455 C WH-18 SIGNAL
23 H401-A204 TN-18 F708-A119 TN-18 A700-A23 TN-18 2 2 A700-F3 143-2455 999-F23 143-2455 998-F22 143-2455 B BK-18 DIGITAL RET

103-A133
BATTERY POWER (+) 22 103-A180 TN-8 150-A159 TN-16 1 1 996-F21 143-2455 A OR-18 +13V DIGITAL
21 F705-A62 TN-18
20 F718-A61 TN-18 A-C11 G-C1
19 CONN12A CONN12B UNFILTERED OIL

30
TN-18
(+)
8N-1513

86
STARTER SOL DRIVE (-) 18 E799-A182 TN-18 F701-A185 TN-18 16A 103-A134 TN-16 8N1514 G-C2 PRESSURE SENSOR
17 E799-A182 TN-18 A283-A154 TN-16 993-A24 TN-18 37 37 993-G23 143-2455 8T8732 212-3421

SWDR
(-) CABLE 9

RELAY
GN-18

9Y2921
PRELUBE PUMP RELAY DRIVE (-) 16 F705-A62 TN-18 993-A25 TN-18 36 36 993-G20 143-2455 E796-G1 143-2455 C SIGNAL
SWITCHED BREAKER YL-18

85
15 SWDCB 993-A26 TN-18 35 35 993-G17 143-2455 993-G2 143-2455 B ANALOG RET

87

SWITCHED POWER
OR-18

87A
AIR SHUTOFF RELAY DRIVE (-) 14 F700-A112 TN-18 998-A184 TN-18 1346297 993-A27 TN-18 34 34 993-G14 143-2455 997-G3 143-2455 A +V ANALOG

TO

BOX
13 993-A28 TN-18 33 33 993-G11 143-2455

POWER

9
AIR SHUTOFF RELAY DRIVE (+) 12 F708-A119 TN-18 183-A155 TN-16 993-A29 TN-18 32 32 993-G8 143-2455 FILTERED OIL
11 150-A135 TN-14 993-A30 TN-18 31 31 993-G5 143-2455 G-C3 PRESSURE SENSOR

A287-A197
A287-A196
A287-A195
9

8T8732 212-3421

DISTRIBUTION
10 150-A136 TN-14 993-A31 TN-18 30 30 993-G2 143-2455 997-G3 143-2455 CABLE 10
9 F700-A112 TN-18 29 29 997-G6 143-2455 994-G4 143-2455 C GN-18 SIGNAL

30
YL-18

86
8 16A 28 28 997-G9 143-2455 993-G5 143-2455 B ANALOG RET
(+) OR-18
7 27 27 A +V ANALOG

TN-18
TN-18
TN-18
PRIMARY ECM
103-A137 TN-18 997-G12 143-2455 997-G6 143-2455

PECMR
RELAY

9Y2921
6 PECMCB A287-A198 TN-18 26 26 997-G15 143-2455

85

PRIMARY ADEM
PRELUBE PRESS SWITCH 5 F718-A61 TN-18 1141143 25 25 997-G18 143-2455 UNFILTERED FUEL

87

87A
4 103-A54 TN-14 997-A46 TN-18 24 24 997-G21 143-2455 G-C4 PRESSURE SENSOR
PRELUBE PRESS SWITCH 3 998-A184 TN-18 103-A202 TN-14 997-A40 TN-18 23 23 997-G24 143-2455 8T8732 212-3421
CABLE 11
STARTER SOL DRIVE (+) 2 F701-A185 TN-18 997-A41 TN-18 22 22 F737-G7 143-2455 C GN-18 SIGNAL
1 997-A42 TN-18 21 21 993-G8 143-2455 B YL-18 ANALOG RET
997-A43 TN-18 20 20 997-G9 143-2455 A OR-18 +V ANALOG
997-A44 TN-18 19 19 993-G2 143-2455
S1

18 997-A45 TN-18 18 18 993-G5 143-2455 FILTERED FUEL

DOUBLE POLE BUS

17 17 G-C5 PRESSURE SENSOR

1319124
17 997-A47 TN-18 993-G8 143-2455
NC 16 16 8T8732 212-3421
16 993-A25 TN-18 A751-A32 TN-18 A751-G22 143-2455 993-G11 143-2455 CABLE 12
GN-18

(-)
(+)
COM 15 F700-A112 TN-18 993-A24 TN-18 995-A33 TN-18 15 15 995-G19 143-2455 993-G14 143-2455 F725-G10 143-2455 C SIGNAL
YL-18

CRANK TERM
14 F708-A63 TN-18 993-A28 TN-18 A747-A34 TN-18 14 14 A747-G16 143-2455 993-G17 143-2455 993-G11 143-2455 B ANALOG RET
NO OR-18
13 ESSS-A8 CABLE 993-A27 TN-18 A746-A35 TN-18 13 13 A746-G13 143-2455 993-G20 143-2455 997-G12 143-2455 A +V ANALOG
AYA-C1 NC 12 412-A132 TN-18 ESS1-A10 CABLE 993-A29 TN-18 F725-A36 TN-18 12 12 F725-G10 143-2455 993-G23 143-2455
8T9735 11 ESS2-A16 CABLE 103-A138 TN-18 993-A26 TN-18 F737-A37 TN-18 11 11 F737-G7 143-2455 TURBO OUTLET
COM
C 10 10 10 G-C6 PRESSURE SENSOR

OVERSPEED
F700-A112 TN-18 993-A30 TN-18 994-A38 TN-18 994-G4 143-2455

30
8T8732 212-3420

86
D NO 9 103-A137 TN-18 103-A137 TN-18 993-A31 TN-18 E796-A39 TN-18 9 9 E796-G1 143-2455

2
CABLE 13
GN-18

ARE TO BE CREATED BY
E 8 103-A131 TN-18 103-A131 TN-18 P972-A10 TN-18 A751-A32 TN-18 997-A40 TN-18 8 8 997-G24 143-2455 E796-G1 143-2455 A746-G13 143-2455 C SIGNAL

103-A202
+

OVS
F708-A51 TN-18 YL-18

USING CABLE # 144-1104

9D3721
SWITCH
A 7 7 7 B ANALOG RET
150-A66

VDC
ISDR
P971-A8 TN-18 1
995-A33 TN-18 997-A41 TN-18 997-G21 143-2455 994-G4 143-2455 993-G14 143-2455

B-40
RELAY

9Y2921
F708-A63 TN-18 OR-18

85
B - 6 A747-A34 TN-18 997-A42 TN-18 6 6 997-G18 143-2455 F737-G7 143-2455 997-G15 143-2455 A +V ANALOG

MODULE
103-A73 TN-18

87
OVERSPEED VERIFY

87A
F 5 A287-A72 TN-18 A746-A35 TN-18 997-A43 TN-18 5 5 997-G15 143-2455 F725-G10 143-2455
SIG

INDEPENDENT SHUTDOWN
G 4 4 4

TN-14
ESS2-A16 CABLE F737-A37 TN-18 997-A44 TN-18 997-G12 143-2455 A746-G13 143-2455 AMBIENT

FOR USE WITH

CIRCUITS ESSS, ESS1, AND ESS2
TN-18

H COM 3 ESS1-A10 CABLE 103-A140 TN-18 994-A38 TN-18 997-A45 TN-18 3 3 997-G9 143-2455 A747-G16 143-2455 G-C7 PRESSURE SENSOR

PICK-UP

WOODWARD LOADSHARE
J ESSS-A8 CABLE 412-A132 TN-18 F725-A36 TN-18 997-A46 TN-18 2 2 997-G6 143-2455 995-G19 143-2455 8T8732 212-3422
SHLD 2 CABLE 14
1 F708-A51 TN-18 E796-A39 TN-18 997-A47 TN-18 1 1 997-G3 143-2455 A751-G22 143-2455 A747-G16 143-2455 C GN-18 SIGNAL
993-G17 143-2455 B YL-18 ANALOG RET
ELECTRIC SPEED OR-18
SWITCH 103-A73 TN-18 997-G18 143-2455 A +V ANALOG
4W9733
103-A52

A287-A72 TN-18 010-A170 TN-18 A-C12

30
86
1010204

8
AY-C1 A-C7 020-A169 TN-18 COOLANT
8T9735 9W1951 070-A113 TN-18 030-A168 TN-18 103-A87 TN-18 F725-A36 TN-18 892-A48 TN-18 3 CAT DATA LINK1 (-) G-C8 TEMP SENSOR

SDNR
8

8T8731 1027532

RELAY
1 C C

9Y2921
070-AY1 TN-18 070-A113 TN-18 080-A105 TN-18 A287-A88 TN-18 E796-A39 TN-18 893-A49 TN-18 9 CAT DATA LINK1 (+) CABLE 15
TN-14

WH-18

85
2 080-AY2 TN-18 D D 080-A105 TN-18 090-A106 TN-18 999-A9 TN-18 J982-A50 TN-18 1 GLOBAL CAT LINK (-) 995-G19 143-2455 C SIGNAL

SHUTDOWN NOTIFY
87
BK-18

87A
3 090-AY3 TN-18 E E 090-A106 TN-18 F702-A109 TN-18 F795-A11 TN-18 F715-A179 TN-18 2 SHUTDOWN SIG 'C' 993-G20 143-2455 B ANALOG RET
+B A A 4 A OR-18 +V ANALOG

SP DROOP1
103-AY4 TN-18 103-A71 TN-18 F722-A58 TN-18 996-A17 TN-18 103-A52 TN-14 +BATTERY 997-G21 143-2455
-B B B 5

MODULE
998-AY5 TN-18 998-A107 TN-18 F721-A60 TN-18 A287-A53 TN-14 -BATTERY
2 3
D F722-AY6 TN-18 F F F722-A58 TN-18 F702-A108 TN-18 F717-A59 TN-18 103-A54 TN-14 6 +BATTERY
S F702-AY7 TN-18 G G F702-A108 TN-18 998-A107 TN-18 F716-A56 TN-18 J981-A55 TN-18 7 GLOBAL CAT LINK (+) G-C9 TEMP SENSOR

SIGNAL CONNECTOR
8T8731 212-3224

STANDARD OPTION
H H 8

SPEED/DROOP INPUT
F702-A109 TN-18 103-A71 TN-18 113-A64 TN-18 F716-A56 TN-18 START/RUN/STOP1

WOODWARD LOADSHARE
CABLE 16

NOT FOR USE WITH

CONTROL GP WH-18
9X9591 J J H401-A204 TN-18 103-A54 TN-14 10 CAN DATA LINK (-) (UNUSED) A751-G22 143-2455 C SIGNAL
BK-18

8D2676
SWITCH
150-A66 TN-18 A287-A57 TN-14 11 -BATTERY 993-G23 143-2455 B ANALOG RET

LOW IDLE
12 A OR-18 +V ANALOG

F702-A104
POSSIBLE.

A-C8 103-A52 TN-14 F724-A110 TN-18 TIMING CAL (-) 997-G24 143-2455
9W1951 412-A132 TN-18 F722-A58 TN-18 13 DROOP SIGNAL
POSSIBLE.

A 103-A188 TN-18 F708-A51 TN-18 F717-A59 TN-18 14 START/RUN/STOP2

B A287-A189 TN-18 F715-A179 TN-18 15 (J1939 SHIELD GROUND)

TN-18
C F719-A178 TN-18 16 CAN DATA LINK (+) (UNUSED)

CONNST1
D 893-A190 TN-18 F725-A36 TN-18 17 FUEL PRESSURE - FILTERED
E 892-A191 TN-18 F722-A58 TN-18 F723-A111 TN-18 18 TIMING CAL (+)
F F705-A62 TN-18 F721-A60 TN-18 19 ECS IN AUTO STATUS
G F718-A61 TN-18 F718-A61 TN-18 20 PRELUBE PRESSURE/OVERRIDE SWITCH
H J982-A192 TN-18 F701-A185 TN-18 A287-A53 TN-14 F705-A62 TN-18 21 PRELUBE PUMP
J J981-A193 TN-18 E799-A182 TN-18 997-A70 TN-18 22
A287-A57 TN-14 113-A64 TN-18 23 ECM ON/OFF - KEYSWITCH INPUT

5
2
F719-A178 TN-18 24 SHUTDOWN SIGNAL 'D'
CIRCUITS 892-WH AND 893-WH MUST BE
J1

993-A68 TN-18 25

COS

POSSIBLE.
SWITCH

6T1767
CONNPJ1

26
TWISTED TOGETHER AND KEPT AS SHORT AS

998-A67 TN-18 412-A132 TN-18 LOW IDLE

27

6
4
3
1
150-A66 TN-18 OVERSPEED VERIFY
CIRCUITS J981-WH AND J982-WH MUST BE

POSSIBLE.
TWISTED TOGETHER AND KEPT AS SHORT AS

CRANK OVERRIDE
103-A141 TN-18 F708-A51 TN-18 28 AIR SHUTOFF DRIVE (+)
F701-A81 TN-18 998-A67 TN-18 29 DIG SNSR RETURN
E799-A77 TN-18 993-A68 TN-18 30 ANA SNSR RETURN
F795-A11 TN-18 31 CRANKCASE PRESSURE SENSOR
892-A48 TN-18 996-A17 TN-18 32 PRIMARY +13V SPEED/TIMING
893-A49 TN-18 33
A700-A69 TN-18 A700-A69 TN-18 35 DIG SNSR PWR (8V)

7
J982-A50 TN-18 997-A70 TN-18 36 ANA SNSR PWR (5V)
7

A-C6 J981-A55 TN-18 E796-A39 TN-18 37 OIL PRESSURE - UNFILTERED

3E3361 999-A9 TN-18 38 PRIMARY ENG SPEED/TIMING SIG
1 39

CIRCUITS 892-WH AND 893-WH MUST BE

F723-A111 TN-18 F724-A110 TN-18
2 F724-A110 TN-18 F723-A111 TN-18 34

TWISTED TOGETHER AND KEPT AS SHORT AS

40

CIRCUITS J981-WH AND J982-WH MUST BE

A-C13

TWISTED TOGETHER AND KEPT AS SHORT AS

1010205
A751-A32 TN-18 F704-A15 TN-18 1 RH TURBO EXHAUST TEMP
A-C3 F737-A37 TN-18 F714-A13 TN-18 2 TURBO INLET RH PRESSURE SNSR
8T9834 3
A287-A194

A746-A35 TN-18 F737-A37 TN-18 FUEL PRESSURE SNSR - UNFILTERED

40 103-A73 TN-18 A287-A189 TN-18 995-A33 TN-18 G770-A74 TN-18 4 SOL 14 & 16 RETURN
39 103-A65 TN-18 103-A71 TN-18 A747-A34 TN-18 F726-A75 TN-18 5 SOL 1 & 3 RETURN
38 A287-A163 TN-18 994-A38 TN-18 G785-A76 TN-18 6 SOLENOID 14 POWER
TN-18

37 997-A40 TN-18 A287-A160 TN-18 F704-A15 TN-18 E799-A77 TN-18 7 3.5A PWM RETURN
36 997-A46 TN-18 A287-A199 TN-14 A746-A12 TN-18 994-A38 TN-18 8 OIL PRESSURE SNSR - FILTERED
35 997-A21 TN-18 A287-A200 TN-14 F714-A13 TN-18 995-A33 TN-18 9 COOLANT TEMPERATURE SNSR
ENGINE

34 A287-A194 TN-18 103-A73 TN-18 F703-A14 TN-18 G786-A78 TN-18 10 SOLENOID 16 POWER
33 A287-A160 TN-18 A287-A72 TN-18 103-A87 TN-18 F727-A79 TN-18 11 SOL 2 & 4 RETURN
32 A287-A163 TN-18 A287-A194 TN-18 A287-A88 TN-18 G784-A80 TN-18 12 SOLENOID 12 POWER
31 A287-A195 TN-18 F702-A104 TN-18 F701-A81 TN-18 13 STARTER MOTOR CRANK
30 103-A71 TN-18 A287-A196 TN-18 E799-A77 TN-18 A746-A12 TN-18 14 TURBO INLET LH PRESSURE SNSR
29 A287-A197 TN-18 F701-A81 TN-18 A751-A32 TN-18 15 AFTERCOOLER TEMPERATURE SNSR
28 A287-A198 TN-18 G771-A82 TN-18 16 SOLENOID 1 POWER
27 997-A44 TN-18 103-A65 TN-18 G770-A74 TN-18 F728-A83 TN-18 17 SOL 5 & 7 RETURN
26 997-A43 TN-18 997-A19 TN-18 G769-A100 TN-18 G783-A84 TN-18 18 SOLENOID 10 POWER
25 997-A47 TN-18 997-A20 TN-18 F731-A95 TN-18 19 POUT 1 (UNUSED)
24 A287-A189 TN-18 997-A21 TN-18 F726-A75 TN-18 A747-A34 TN-18 20 ATMOSPHERIC PRESSURE SNSR
23 21 SOL 6 & 8 RETURN

SB1
A287-A195 TN-18 997-A41 TN-18 F727-A79 TN-18 F729-A85 TN-18
J2

22 A287-A196 TN-18 997-A43 TN-18 F728-A83 TN-18 G782-A86 TN-18 22 SOLENOID 8 POWER
CONNPJ2

21 997-A46 TN-18 F729-A85 TN-18 A746-A35 TN-18 23 TURBO OUTLET PRESSURE SNSR
20 997-A42 TN-18 F730-A90 TN-18 F702-A104 TN-18 24 DESIRED ENGINE SPEED
19 997-A45 TN-18 G785-A76 TN-18 F703-A14 TN-18 25 LH TURBO EXHAUST TEMP

SPLICE BLOCK - CONNECTOR 1

18 997-A44 TN-18 G786-A78 TN-18 G772-A89 TN-18 26 SOLENOID 3 POWER

6
17 997-A45 TN-18 997-A47 TN-18 G784-A80 TN-18 F730-A90 TN-18 27 SOL 9 & 11 RETURN
16 997-A42 TN-18 997-A40 TN-18 G783-A84 TN-18 G781-A91 TN-18 28 SOLENOID 6 POWER
6

15 997-A41 TN-18 997-A70 TN-18 G777-A92 TN-18 103-A87 TN-18 29 SHUTDOWN NOTIFY RELAY DRIVE
14 A287-A197 TN-18 A287-A57 TN-14 G776-A93 TN-18 G777-A92 TN-18 30 SOLENOID 13 POWER
13 A287-A53 TN-14 G778-A97 TN-18 G776-A93 TN-18 31 SOLENOID 11 POWER
12 A287-A72 TN-18 G775-A98 TN-18 G773-A94 TN-18 32 SOLENOID 5 POWER
11 A287-A57 TN-14 G782-A86 TN-18 F731-A95 TN-18 33 SOL 10 & 12 RETURN
10 G774-A99 TN-18 G780-A96 TN-18 34 SOLENOID 4 POWER
9 G781-A91 TN-18 A287-A88 TN-18 35 SHUTDOWN NOTIFY RELAY RETURN
8 G773-A94 TN-18 G778-A97 TN-18 36 SOLENOID 15 POWER
7 997-A19 TN-18 G780-A96 TN-18 G775-A98 TN-18 37 SOLENOID 9 POWER
6 997-A20 TN-18 G772-A89 TN-18 G774-A99 TN-18 38 SOLENOID 7 POWER
5 997-A70 TN-18 G779-A101 TN-18 G769-A100 TN-18 39 SOL 13 & 15 RETURN
4 A287-A53 TN-14 G771-A82 TN-18 G779-A101 TN-18 40 SOLENOID 2 POWER
3 A287-A198 TN-18
2 A287-A199 TN-14
1 A287-A200 TN-14
A-C4
8T9834
40 H401-A204 TN-18
39
38 A-C14
J-C1
37 CONN10A
CONN10B J-C2
3T3410
36 993-A5 TN-18 998-A107 TN-18 3T3412 CABLE INJ1 1564588
35 993-A4 TN-18 998-A203 TN-18 G771-A82 TN-18 G771-A82 TN-18 1 1 G771-J1 143-2456 G771-J1 143-2456 1
34 993-A3 TN-18 998-A184 TN-18 G779-A101 TN-18 F726-A114 TN-18 2 2 F726-J2 143-2456 F726-J2 143-2456 2 TO INJECTOR #1
33 998-A177 TN-18 G772-A89 TN-18 G779-A101 TN-18 3 3 G779-J3 143-2456 J-C3
32 998-A107 TN-18 993-A3 TN-18 G780-A96 TN-18 F727-A115 TN-18 4 4 F727-J4 143-2456 CABLE INJ2 1564588
31 998-A177 TN-18 993-A4 TN-18 G773-A94 TN-18 G772-A89 TN-18 5 5 G772-J5 143-2456 G779-J3 143-2456 1
30 998-A1 TN-18 G781-A91 TN-18 F726-A116 TN-18 6 6 F726-J6 143-2456 F727-J4 143-2456 2 TO INJECTOR #2
29 F731-A95 TN-18 998-A6 TN-18 G774-A99 TN-18 G780-A96 TN-18 7 7 G780-J7 143-2456 J-C4
28 G769-A100 TN-18 998-A7 TN-18 G782-A86 TN-18 F727-A117 TN-18 8 8 F727-J8 143-2456 CABLE INJ3 1564588
27 G770-A74 TN-18 993-A5 TN-18 F726-A114 TN-18 G773-A94 TN-18 9 9 G773-J9 143-2456 G772-J5 143-2456 1
26 993-A25 TN-18 993-A25 TN-18 F727-A115 TN-18 F728-A118 TN-18 10 10 F728-J10 143-2456 F726-J6 143-2456 2 TO INJECTOR #3
25 993-A31 TN-18 993-A31 TN-18 F726-A116 TN-18 G781-A91 TN-18 11 11 G781-J11 143-2456 J-C5

5
24 993-A30 TN-18 993-A30 TN-18 F727-A117 TN-18 F729-A120 TN-18 12 12 F729-J12 143-2456 CABLE INJ4 1564588
5

23 13 13 1

SB2
993-A26 TN-18 F728-A118 TN-18 G774-A99 TN-18 G774-J13 143-2456 G780-J7 143-2456
22 998-A67 TN-18 993-A29 TN-18 F729-A120 TN-18 F728-A121 TN-18 14 14 F728-J14 143-2456 F727-J8 143-2456 2 TO INJECTOR #4
21 15 15

OF CONTROL GP 126-5531
998-A7 TN-18 993-A27 TN-18 F728-A121 TN-18 G782-A86 TN-18 G782-J15 143-2456 J-C6

CIRCUIT REPRESENTATION OF
20 F715-A179 TN-18 993-A28 TN-18 F729-A122 TN-18 F729-A122 TN-18 16 16 F729-J16 143-2456 CABLE INJ5 1564588
19 F731-A123 TN-18 993-A24 TN-18 17 17 G773-J9 143-2456 1
TO INJECTOR #5

SPLICE BLOCK - CONNECTOR 2

I1

18 G769-A126 TN-18 993-A68 TN-18 18 18 F728-J10 143-2456 2

17 G770-A129 TN-18 998-A67 TN-18 19 19 J-C7
16 993-A26 TN-18 F731-A95 TN-18 20 20 CABLE INJ6 1564588
15 993-A27 TN-18 G769-A100 TN-18 21 21 G781-J11 143-2456 1
14 993-A29 TN-18 G770-A74 TN-18 22 22 F729-J12 143-2456 2 TO INJECTOR #6
13 23 23 J-C8
12 998-A203 TN-18 F715-A179 TN-18 24 24 CABLE INJ7 1564588
11 F719-A178 TN-18 25 25 G774-J13 143-2456 1
10 F719-A178 TN-18 H401-A204 TN-18 26 26 F728-J14 143-2456 2 TO INJECTOR #7
9 F731-A125 TN-18 27 27 J-C9
8 G769-A128 TN-18 F731-A123 TN-18 28 28 CABLE INJ8 1564588
7 G770-A127 TN-18 G769-A126 TN-18 29 29 G782-J15 143-2456 1
6 993-A28 TN-18 G770-A129 TN-18 30 30 F729-J16 143-2456 2 TO INJECTOR #8
FOR 3512B

5 993-A24 TN-18 F731-A125 TN-18 31 31

4 993-A68 TN-18 G769-A128 TN-18 32 32
3 998-A1 TN-18 G770-A127 TN-18 33 33
2 998-A6 TN-18 34 34
1 998-A184 TN-18 35 35
A-C5 36 36
8T9834 37 37
40 J981-A193 TN-18 A-C15 K-C1
39 J982-A192 TN-18 CONN11A CONN11B
38 893-A190 TN-18 892-A191 TN-18 3T3410 3T3412
37 892-A191 TN-18 893-A190 TN-18 1 1
FOR 3516B

36 2 2
35 3 3
34 4 4
33 893-A161 TN-18 5 5

4
4

32 6 6
SB3

892-A162 TN-18 K-C2

31 J981-A164 TN-18 7 7 CABLE INJ9 1564588
30 A700-A23 TN-18 J982-A165 TN-18 8 8 G775-K1 143-2456 1
29 F703-A2 TN-18 9 9 F730-K2 143-2456 2 TO INJECTOR #9
28 893-A161 TN-18 A700-A22 TN-18 10 10 K-C3
SPLICE BLOCK - CONNECTOR 3

27 892-A162 TN-18 A700-A23 TN-18 11 11 CABLE INJ10 1564588

26 F729-A85 TN-18 893-A49 TN-18 12 12 G783-K3 143-2456 1
25 F728-A83 TN-18 892-A48 TN-18 13 13 F731-K4 143-2456 2 TO INJECTOR #10
24 J981-A164 TN-18 14 14 K-C4
23 J982-A165 TN-18 J982-A50 TN-18 15 15 CABLE INJ11 1564588
22 F727-A79 TN-18 J981-A55 TN-18 16 16 G776-K5 143-2456 1
TO INJECTOR #11
I2

21 F726-A114 TN-18 A700-A69 TN-18 17 17 F730-K6 143-2456 2

20 A700-A22 TN-18 18 18 K-C5
19 F730-A124 TN-18 19 19 CABLE INJ12 1564588
18 20 20 G784-K7 143-2456 1
17 F726-A75 TN-18 21 21 F731-K8 143-2456 2 TO INJECTOR #12
16 F729-A120 TN-18 F727-A79 TN-18 G775-A98 TN-18 G775-A98 TN-18 22 22 G775-K1 143-2456 K-C6
15 F728-A118 TN-18 F728-A83 TN-18 G783-A84 TN-18 F703-A2 TN-18 23 23 F730-K2 143-2456 CABLE INJ13 1564588
14 J981-A193 TN-18 F729-A85 TN-18 G776-A93 TN-18 G783-A84 TN-18 24 24 G783-K3 143-2456 G777-K9 143-2456 1
13 J982-A192 TN-18 F730-A90 TN-18 G784-A80 TN-18 F731-A123 TN-18 25 25 F731-K4 143-2456 G769-K10 143-2456 2 TO INJECTOR #13
12 F727-A115 TN-18 F727-A115 TN-18 G777-A92 TN-18 G776-A93 TN-18 26 26 G776-K5 143-2456 K-C7
11 F726-A116 TN-18 F726-A116 TN-18 G785-A76 TN-18 F730-A124 TN-18 27 27 F730-K6 143-2456 CABLE INJ14 1564588
10 A700-A69 TN-18 F728-A118 TN-18 G778-A97 TN-18 G784-A80 TN-18 28 28 G784-K7 143-2456 G785-K11 143-2456 1
9 F730-A90 TN-18 F729-A122 TN-18 G786-A78 TN-18 F731-A125 TN-18 29 29 F731-K8 143-2456 G770-K12 143-2456 2 TO INJECTOR #14
8 893-A49 TN-18 F728-A121 TN-18 F731-A123 TN-18 G777-A92 TN-18 30 30 G777-K9 143-2456 K-C8
7 892-A48 TN-18 F727-A117 TN-18 F731-A125 TN-18 G769-A126 TN-18 31 31 G769-K10 143-2456 CABLE INJ15 1564588
6 F729-A122 TN-18 F729-A120 TN-18 G769-A126 TN-18 G785-A76 TN-18 32 32 G785-K11 143-2456 G778-K13 143-2456 1
5 F728-A121 TN-18 F726-A114 TN-18 G770-A127 TN-18 G770-A127 TN-18 33 33 G770-K12 143-2456 G769-K14 143-2456 2 TO INJECTOR #15
4 J981-A55 TN-18 G769-A128 TN-18 G778-A97 TN-18 34 34 G778-K13 143-2456 K-C9
3 J982-A50 TN-18 G770-A129 TN-18 G769-A128 TN-18 35 35 G769-K14 143-2456 CABLE INJ16 1564588
2 F727-A117 TN-18 F730-A124 TN-18 F703-A2 TN-18 G786-A78 TN-18 36 36 G786-K15 143-2456 G786-K15 143-2456 1
1 F726-A75 TN-18 F703-A2 TN-18 F730-A124 TN-18 G770-A129 TN-18 37 37 G770-K16 143-2456 G770-K16 143-2456 2 TO INJECTOR #16

3
3

133-6501

2
2

DIAGRAM-WIRING
(PREMIUM WIRING)
(MARINE AUX-3512/3516)

1
1

A
B
C
D
E
F
G
H
I

Electric Speed Sensor

RH Turbo Inlet Pressure Sensor
RH Exhaust Temperature Sensor

Coolant Temperature Sensor

Boost

WITH SCAC APPLICATION

Ambient

AFTERCOOLER TEMP SENSOR

3516B RIGHT SIDE VIEW

Filtered Oil Pressure Sensor

HOSE & ADAPTER LOCATION

3516B FRONT VIEW

Crankcase Pressure Sensor

MANIFOLD
Filtered Fuel Pressure Sensor
Unfiltered Fuel Pressure Sensor

Aftercooler Temperature Sensor

Unfiltered Oil Pressure Sensor

LH Turbo Inlet Pressure Sensor