Headlights R115-4389 B 01

R115-4389
JBB NKW JW DISP = N-RI NDA = N 05-18-92 LWD NKW JW DISP = N-RI NDA = N 11-10-89
B NKW DLD ADDED GROUND TO REFLECT A NKW MMM C7 ADDED DIODE JUMPER
ACTUAL WIRING W/CONNECTORS
PCR 824-89

GENERAL NOTES:

1) USE ON W900B,T600 AND T800 WITH DAYTIME

RUNNING LIGHTS.

2) CLASSIFICATION OF CHARACTERISTICS
STR THIS DRAWING/SPECIFICATION USES
SYMBOLS TO CLASSIFY CHARACTERISTICS.
SEE CHARGE AND START THESE SYMBOLS ARE DEFINED IN QMS002
WIRING DIAGRAM "CLASSIFICATION OF CHARACTERISTICS".
KEY SWITCH DRL CAB THE CLASSIFICATION OF THE CIRCUIT
SECT HARN AS IT APPLIES TO THIS HARNESS,
8
9 INCLUDING BUT NOT LIMITED TO: WIRE
HEAD LIGHT DRL CAB GAUGE, POSITION IN CONNECTORS,
DIMMER POWER DIST HEADLAMP CONNECTORS, TERMINALS.
P21AL RELAY RELAY SECT HARN
BOX HARNESS
BLK
L6LB
R5HL RED/BLK
L BLU L7HB 3) INDICATES A SPLICE.
CB# 13 BLU/WHT
R5HL 4 8 WAY MOLDED CONNECTOR.
C C
L BLU
30 AMPS
5 6 WAY MOLDED CONNECTOR.
L7HB
BLU/WHT 6 3 WAY WEATHER PACK CONNECTOR.
BATTERY BUS
BAR 11
7 2 WAY HARDSHELL CONNECTOR.
SPARE DRL CAB
CKT HARN SECT HARN 8 16 WAY MOLDED CONNECTOR.
TO SPARE SEE R115-4013
IGN CKT
R5HL
L BLU PCB 1,2, 9 1 WAY WEATHER PACK CONNECTOR.
TO SPARE 3 OR 4
BAT CKT 10 2 WAY WEATHER PACK CONNECTOR.
SPARE DRL CAB
CKT HARN SECT HARN 11 1 WAY BULLET CONNECTORS.
POWER DIST 11
BOX POWER DIST 12 8 WAY HARDSHELL CONNECTORS.
4 BOX
INSTRUMENT 4 13) DRL SYSTEM PROVIDES A REDUCED
PANEL HARN INSTRUMENT VOLTAGE TO THE LOW BEAM HEADLAMPS
PNL HARN BAT C19SR
RED ORN WHEN THE TRUCK IS OPERATING. THE
DRL’S WILL BE OFF WHEN THE PARK
10 BRAKE IS APPLIED AND DURING CRANKING.
IGN
R5HL GRN DRL CAB HEADLAMP 14) RED-BAT PWR
L BLU SECT HARN HARNESS
L7HB NOT WHT-LO BEAM (DRL) OUTPUT
BLU/WHT L6LB ORN-CRANK DISABLE
USED
RED/BLK GRN-IGN PWR
L7HB
R5DS YEL-PARK BRAKE
BLU/WHT
L BLU BLK-GND
BLU-HI BEAM SENSOR
GND GND GND
WHT WHT WHT
L6LB
RED/BLK
L7HB
INSTRUMENT
BLU/WHT
PANEL HARN
5
TACHOMETER
GROUND TO PNL HARN
MAIN CAB
GROUND L7HB HEADLAMP HEADLAMP
BLU/WHT HARNESS HARNESS
6 6
INSTRUMENT HEADLAMP HEADLAMP
PANEL HARN GND ASSEMBLY ASSEMBLY
4 WHT
SWITCH PANEL HIGH BEAM
HARNESS INSTRUMENT L6LB
IND LAMP IGN GND
PANEL HARN RED/
GRN WHT
7 BLK
DRL CAB
SECT HARN L7HB
R5HL BAT C19SR
L BLU BLU/
RED ORN
WHT LOW LOW
DIODE JUMPER BEAM BEAM
A
HARNESS
SEE TAIL LAMP PRK BRK
HIGH HIGH
WIRING DIAGRAM YEL DRL CAB BEAM BEAM
DIODE JUMPER SECT HARN
12
HARNESS DRL MODULE
HDLP GND GND
ASSY
L BLU

R1PL DRL CAB DRL CAB YEL GRN WHT BLK

SECT HARN SECT HARN B
7
DIMMER RED ORN BLU
SWITCH PARK BRAKE
ASSEMBLY SWITCH

HDLP
L BLU DIST
DRL LH DUAL RH DUAL B
MODULE C
HD LAMPS HD LAMPS
(SHOWN) (SHOWN)
HEAD LIGHT
SWITCH D
GND GND E
F
G
DIMMER SWITCH H
(IN TURN SIGNAL SWITCH-STD-, SINGLE HEADLAMPS: I
FLOOR MTD-OPT) WIRED SAME AS HIGH
(CASE GROUND) LOW BEAM HEADLAMPS
J
Kf
4 L
M
N
SIGNATURE ON FILE SIGNATURE ON FILE O
MASCHO WILHOYTE R CRAIG
SIGNATURE ON FILE
N WONG
SIGNATURE ON FILE DIAGRAM-
N WONG HEADLIGHTS
X
10-19-89 NONE
PCR 824-89 1 P
R115-4389
EPR 28846E

R115-4389.FM