RTV Gas

1
Safety Data Sheet (SDS)

Industrial Use Only
1. Product and Company Identification
Product:
Product Name: SS-300 Gasoline Resistant Silicone RTV
Intended Use: Sealant
Manufacturer/Supplier:
Silicone Solutions
338 Remington Road
Cuyahoga Falls, OH
Preparer: Casey Linx
Chemical Family: Silicone Rubber
Emergency Telephone Number: 330-920-3125
2. Hazards Identification
Classification of the substance or mixture:

Not classified
GHS label Elements:

Signal word: No signal word
Hazard statements: No known significant effects or critical hazards
Precautionary Statements:
General: Not applicable
Prevention: Not applicable
Response: Not applicable
Storage: Not applicable
Disposal: Not applicable
Other Hazard Information:

 This product can generate formaldehyde upon exposure above 300 degrees centigrade in atmospheres that contains
oxygen. Formaldehyde is a skin, eye, and throat irritant.
3. Composition/Information on Ingredients
Chemical Characterization:
Formula: Mixture
Composition and Information on Ingredients: Non-hazardous components of the mixture unless otherwise specified.
Component CAS # Approximate % Weight
Vinyl Oximino Silane 2224-33-1 1-5
There are no additional ingredients present which, within the current knowledge of the supplier and in the
concentrations applicable, are classified as hazardous to health or the environment and hence require reporting in this
section.
2
4. First Aid Measures
General Information:
Ingestion: None known.
Skin: Wash with soap and water.
Inhalation: None known.
In case of eye contact: Flush with water for fifteen minutes and get medical attention.
Note to Physician: None known.
5. Firefighting Measures
Flammability Properties:
Flash Point: 315C or 600F
Ignition Temperature: Unknown
Flammable Limits in Air-Upper % : NA
Flammability Limits in Air-Lower % : NA
Sensitivity to Mechanical Impact: No
Sensitivity to Static Discharge: No
Extinguishing Media: All standard firefighting material.
Special Firefighting Procedures: None known.
6. Accidental Release Measures
Action to be taken if material is released or spilled: Scrape up and place in an inert material for disposal. See
Section 8 for protective equipment upon exposure and Section 7 for information on safe handling.
7. Handling and Storage
Precautions to be taken during handling and storage: Cure only where appropriate ventilation systems exist, as
seen in Section 8.
8. Exposure Controls/Personal Protection
Control Parameters:
Components with limit values that require monitoring at the workplace:
Component CAS # ACGIH TLV OSHA PEL
TWA STEL TWA STEL
Vinyl Oximino Silane 2224-33-1 NE NE NE NE
Note: Oximino Silanes form Methyl Ethyl Ketoxime upon contact with atmospheric moisture. Provide adequate ventilation to
control exposures within the following exposure guidelines: Vendor Guide TWA: 3 ppm, Vendor Guide STEL: 10 ppm,
AIHA WEEL TWA: 10 ppm
Exposure Controls and Protection:

Engineering Controls: None known.
Respiratory Protection: None required.
Protective Gloves: Cloth gloves.
Eye and Face Protection: Safety glasses.
Other Protective Equipment: None required.
Ventilation: Cure in well-ventilated areas.
3
9. Physical and Chemical Properties
Information on basic physical and chemical properties:

Boiling Point: NA
Vapor Pressure: NA
Vapor Density: NA
Freezing Point: NA
Melting Point: NA
Physical State: Paste.
Odor: Mild.
% Volatile by Volume: < 1
Evaporation Rate: < 1
Specific Gravity: 1.30
Density (kg/m3): 1300
Acid/Alkalinity: Unknown.
pH: NA
VOC: NT
Solubility in Water: Insoluble.
Solubility in Organic Solvents: Partially soluble in toluene.
10. Stability and Reactivity
Chemical Stability:
Stability: Stable.
Reactivity:
Hazardous Polymerization: Will not occur.
Hazardous Thermal Decomposition/Combustion Products:
 Carbon Dioxide
 Carbon Monoxide
 Silicon Dioxide
 Formaldehyde
Conditions to Avoid: None known.
11. Toxicological Information
Product Information on Toxicological Effects:

Acute Oral LD50: Unknown.
Acute Dermal LD50: Unknown.
Acute Inhalation LC50: Unknown.
Ames Test: Unknown.
12. Ecological Information
Ecotoxicity:
Ecotoxicological Information: Unknown.
Chemical Fate Information: Unknown.
13. Disposal Considerations
Disposal Method: Disposal should be made in accordance with federal, state, and local considerations.
4
14. Transport Information
General:
DOT Shipping Name: NA
DOT Hazard Class: Not DOT regulated
DOT Label: NA
UN/NA Label: NA
Placards: None
IATA: NA
IMO IMDG-code: NA
European Class:
RID (OCTI): NA
ADR (ECE): NA
RAR (IATA): NA
15. Regulatory Information
Regulatory Status and Applicable Laws and Regulations:

SARA Section 302: None found.
SARA (311, 312) Hazard Class: None.
SARA (313) Chemicals: None.
CPSC Classification: NA
WHMIS Hazard Class: None.
Export Schedule:
B/HTSUS: 3910.00 Silicones in primary form.
ECCN: EAR99
California Proposition 65: None.
TSCA Inventory Status: All components are of this product are listed (or exempt) on the EPA TSCA inventory.
Hazard Rating Systems:
HMIS (scale 0-4):
 Health = 1
 Flammability = 0
 Reactivity = 0
NFPA (scale 0-4):
 Health = 1
 Flammability = 0
 Reactivity = 0
16. Other Information
Revision Date: 06/20/2016

SDS Preparer: Casey Linx
This product or its components are on the European inventory (EINECS) of existing commercial chemicals. This data is offered
in good faith as typical values and not as a product satisfaction. No warranty, either expressed or implied, is made. The
recommended handling procedures are believed to be generally applicable. However, each user should review these
recommendations in the specific content of the intended use.
Abbreviations and Acronyms:

OSHA: Occupational Safety and Health Administration
ACGIH: American Conference of Governmental Industrial Hygienists
LD50: Lethal Dose, 50 percent
LC50: Lethal Concentration, 50 percent
DOT: US Department of Transportation
IATA: International Air Transport Association
ADR: Accord européen sur le transport des marchandises dangereuses par Route (European Agreement concerning the
International Carriage of Dangerous Goods by Road)
IMDG: International Maritime Code for Dangerous Goods
5
NFPA: National Fire Protection Association (USA)
HMIS: Hazardous Materials Identification System (USA)
WHMIS: Workplace Hazardous Materials Information System (Canada)

RTV Gas

Uploaded by

Copyright:

Available Formats

RTV Gas

Uploaded by

Document Information

Original Title

Copyright

Available Formats

Share this document

Share or Embed Document

Sharing Options

Did you find this document useful?

Is this content inappropriate?

Copyright:

Available Formats

RTV Gas

Uploaded by

Copyright:

Available Formats

1

Safety Data Sheet (SDS)

1. Product and Company Identification

Classification of the substance or mixture:

GHS label Elements:

Other Hazard Information:

4. First Aid Measures

Note to Physician: None known.

Extinguishing Media: All standard firefighting material.

Special Firefighting Procedures: None known.

6. Accidental Release Measures

7. Handling and Storage

8. Exposure Controls/Personal Protection

Exposure Controls and Protection:

9. Physical and Chemical Properties

Information on basic physical and chemical properties:

10. Stability and Reactivity

11. Toxicological Information

Product Information on Toxicological Effects:

12. Ecological Information

13. Disposal Considerations

15. Regulatory Information

Regulatory Status and Applicable Laws and Regulations:

16. Other Information

Revision Date: 06/20/2016

Abbreviations and Acronyms:

You might also like