Air conditioning climate control system

Schematic drawing Delanair MK2

Jaguar XJ6 Series III and XJ­S (early)
Mode Control Switch (R/H)

N N/Y

N/Y B/W

R/W

K B/U

LG B

Wire colour key

B Black
w White
N Brown
Y Yellow
U Blue
G Green
K Pink
R Red
S Slate
Where 2 colours are stated
the First is the primary colour
and the second is the tracer.

Steve Fuller S&K Jagtech 2005

 Main Relay
Wire colour key

G/S ­ 2H U ­ 3H B Black U Blue

W White K Pink
N Brown R Red
Y Yellow S Slate
N/W ­ 21A G Green
B/W ­ 14 B/Y ­ 8 Where 2 colours are stated:
the first is the primary colour and the second is the tracer.

N/Y ­ 86
N/W to Fuse
B/G ­ 11 B N/W ­ 30/51 and to
G/S to fans pin 30/51 U to Resitor Pack r1

R ­ 1H B/U ­ E Y­87

B/W To Mode B/Y to servo

Control
N/Y from
Thermostat
N/W from
B/G to Servo B Earth centre post
pin 21a

85 86 E 8 E 11 E 14

R to Resitor pack r3 Y to Resistor Pack r2

B/U to Mode control

30/51 87 21a h3 21a h1 21a h2

Steve Fuller S&K Jagtech 2005
 Schematic for Jaguar Aircon Climate control XJ6/12 and XJS upto V139501

earth

For Relay pin numbers see

B/G
seperate AirCon relay sheet B/Y
N/Y
Water Temp
B/U B/W Resitor Pack r1, r2 & r3 Transmitter Termostate
A B
0.425
B 0.85 1.275 Servo Control Unit
Blower]
W W W Motor

N N/Y G/B
Main Relay G/S
U Blower]
Y Motor
R
Y/N Y/N
B
N/W G/S in-line fuse
Wire colour key
B Black K Pink 15way block connector on servo
w White R Red NOTE: N/Y
N Brown S Slate Thermostat A: THERMOSWITCH
G/N
Y Yellow P Purple Location­ on inlet pipe of heater matrix R P K N O Y G
U Blue O Orange Thermostat B: RANCO
Location­ right hand side of A/C unit Y/N
G Green N/Y
B/Y
Where 2 colours are stated, B/G
the first is the primary colourand the second
is the tracer.

N
Snap connector R/H side
B/W of engine bay (part of engine loom)

G/N
R
O Y U G W N
P N/Y
11 way block N
connector on Amp
U W/U Compressor
W/G Clutch
Thermal
fuse

Amplifier
in-line fuse B
temp Control Vac Valve Ambient sensor In Car sensor B/W
R/W G/N
Mode Control B

K B B

Over temp switch

G G
Spade connector on
N compressor clutch
K K B B

B/U B/U

earth

Steve Fuller S&K Jagtech 2005

 Jaguar XJ6/S MkII
Delanair Vacuum System

Demist flap actuator L/H Face level front grill Demist flap actuator L/H

Vacuum cut when R/H control set to Defrost

Lower heater flap actuator

Screen vent actuator on R/H switch

Vacuum controlled solenoid

Water valve actuator

Vacuum switches on servo unit

Colours are for ease of reading

but do represent the Harder thin
bore PVC tubing colours used Face level vacuum switch

Blower case flap actuator Blower case flap actuator

To Vac Supply to water valve

Steve Fuller S&K Jagtech 2005

 Pipes to front side of aircon unit
see accompaning diagram for details
of passenger compartment

To Servo (Center Vent Valve)

To Vacuum actuator solenoid
(Blower Vents)
To Lower Flap actuator
Res­o­vac tank (floor vents)
Vacuum supply line
From Servo drive
(water Valve)

To Manifold
Water Valve
Bulkhead
Mount

Jaguar XJ6, 12 and XJ­S Aircon cars

Engine Bay Aircon Vacuum System

Pipe layout and component connections (not to scale)
Steve Fuller S&K Jagtech 2005
 Actuator on mode Cntrl

Servo Unit
To Water
Valve
To Vacuum
Supply

To Mode To Demist Blower Case

Switch Valve Flap actuators flap actuators

Lower heater flap actuator

Jaguar XJ6, 12 and XJ­S Aircon cars
To vacuum supply (white pvc)

Vacuum Solenoid
Internal Vacuum System
Pipe layout and closeups of
component connections
Slight component type variations may apply during manufacture,
however the vacuum connections are the same throughout production
Steve Fuller S&K Jagtech 2005