1 2 3 4 5 6 7 8

E
SIZE
+5VS
+5VS
J4

B
+5VS 6
10PIN +12V
R50 +5VS
722-0003 1
1 2 1
R110
7 J4 10.0K
R89
1.0K 0_OHM
1 10PIN
0.1W 1% 0.1W
1 722-0003 0.1W
C77 1% 15 16
+5VS .01UF C24 9 J4 2 +VIN VREF NA%
50V 0.1UF 2 2

REV
IC6 R41 10% 10PIN
1
NON_INV
VC
13
1S 8 50V 1 1
VCC
1 2
2
2
C17 C21 722-0003
9
INV IC9 14 DC-DC_OUTB
2C 7 10% 0.1UF 22PF 3/D1
A 3D
DU
6
1 C16 20_OHM 1 J4 4
COMP OUT_B
11
3/D1
A
0.1W 1% 50V 50V 1 OSC_OUT OUT_A
ORG .01UF 1 10PIN 6 DC-DC_OUTA 1 1
4Q 5 D 10% 10% 1 C43 RT
VSS 50V D 722-0003 369-0058
C89 2 2
0.1UF
5 3
R10 C42 C39
93C46 10% Y1 CT SYNC
1 1
1
.01UF 1 3 J4 50V 7
DISCHARGE SHTDWN
10 1 2 0.1UF 0.1UF
359-0058 50V 16MHZ 10PIN 10% 50V 50V
R43 R44 2 10% 309-0005
R113 GND CSS
C22 722-0003 2 1 2K 10% 10%
10.0K 10.0K 2 SERIAL_OUT 1 2
0.1W 0.1W R45 22PF 2 5 J4 R112 12 8 1 0.1W 1% 2 2

1% 1% 1.0K D 50V 10PIN

21.5K
0_OHM R5
2 2
D D 1 PE1/RDI
SERIAL_IN IC7 44 PE0/TDO 10% 722-0003 0.1W 0.1W NA% 2K
2 0.1W 2 1 1
2 PB0/PWM3
BEEPER 43 D 1% C55 0.1W
1%
3 PB1/PWM2
PB1 359-0117
VDD_2
42 OSCIN
10 J4 R111 2
1
470PF 1% D
D D 72324
OSC1 10PIN 20K C56 2
4 PB2/PWM1
PB2 OSC2
41 OSCOUT R49 722-0003 50V
0.1W 1000PF
5 PB3/PWM0
PB3 VSS_2
40 1 2 8 J4 10% 16V I_LIMIT 2/B6
1% 2
2/C7 SYNC 6 RESET
39 RESET 10PIN 2
10% D
PB4/ARTCLK
0.1W 10.0K 1% 722-0003 2 PP_ENA 3/C7
7 PD0/AIN0
LINE_SENSE VPP
38 VPP
DCBUS_VSENSE 2/B8
8 PD1/AIN1 PA7/SCLI
37 ON_LINE
3/A1
1 +24V VBATT 9 PD2/AIN2 PA6/SDAI
36 REPLACE_BATTERY D
1
R47 2/B6 I_LOAD 10PD3/AIN3 35 +12V
8.25K
C20 +5VS TEMP 11
PA5
34 ON_BATTERY
.01UF 1 3/E3 PD4/AIN4 PA4 1/E1 R161
0.1W 50V R79 12PD5/AIN5
POW_SWITCH/XL_DETECT VSS_1
33 1 2
1
1% 10% 13VAREF 32 +5VS
49.9K VDD_1
2 2 14VSSA 31 BOOST C97 +5VS 200_OHM
0.1W +5VS PA3 2/A5 D C23 .01UF 24VBATT
0.1W 1%
FAN 15PF0/MCO/AIN8 30 XCAP 50V
+12V 1% 4/A7 PC7/SS/AIN15 3/D7 2 1 R162
D D 2 16
PF1/BEEP PC6/SCK/ICCCLK
29 PHASE1_U 4 J4 10% 1 2
2 SS_LOWBAT 17PF2 28 PHASE2_L 10PIN 3/B5 1 2 1 3
1
PC5/MOSI/AIN14 3/B5
C35 0.1UF D J10 J17
1 1 C38 1 C13 1 C1 2/A6 TRIM 18PF4/OC1A/AIN10 27 PHASE2_U 722-0003 10% 50V 200_OHM 6 6 2 SW1 4
C19 R80 1000PF 1000PF D15 PC4/MISO/ICCDATA 4.7UF 1 3 0.1W 1%
1
6.81K
0.1UF 3 3/D7 INV_ENA 19PF6/ICAP1A PC3/ICAP1B
26 PHASE1_L 3/B6 2 J4 25V D C64 540-0310
22UF 50V 16V 16V 339-0008 Q34 635-0069
CHARGER_ENABLE 20PF7/EXTCLKA 25 RTH_U 3/B6 20% 1000PF +5VISO J10 J17 LED5
3
D37 BZ1
16V
20%
0.1W 10% 10% 10% 4148SE 2/D7
21VDD_0
PC2/ICAP2B
24 RTH_L
3/B3 10PIN 2
16V
1 NPN
AVR_LED 5 5 1 2
B
75V 722-0003
B BEEPER
2 1%
2 2 2 2 22VSS_0
PC1/OC1B/AIN13
23 XFER_RELAY
3/E6,3/B3
10%
2N2222
600MA_75V
2/B6
75V 1 PC0/OC2B/AIN12 2/B4 2 635-0069 GRN
1 2 390-0004 2
D J10 J17
2
D4148CC D D D D D D 4 4
D
R35 D
+5VS XL_BAT +5VS 635-0069
3/D5 1 2
R165 J10 J17 ON BATT LED3

IT BE USED FOR ANY PURPOSE WITOUT THE EXPRESS WRITTEN CONSENT bOF AN AUTHORIZED AGENT OF AMERICAN POWER CONVERSION COMPANY.
AMERICAN POWER CONVERSION COMPANY. IT MAY NOT BE COPIED OR USE D IN ANY MANNER NOR MAY ANY OF THE INFORMATION IN OR UPON

NOTICE OF PROPRIETARY PROPERTY: THIS DOCUMENT AND THE INFORMATIO N CONTAINED IN IT ARE THE PROPRIETARY PROPERTY OF
3 C36 2 1 1 2
1 2 1.0K
2 1 1
R115 0.1W 1% 1
750R 635-0069
YEL
1 1 2 D20 R71
0.1UF 3 1% 0.1W
339-0008
50V 10% D
4148SE
10.0K
R163 J10 J17 REPL BAT LED2
0.1W 1.0K 1%
75V 0.1W 2 1 3 3 1 2

Q32 R116 1% RED

1 2 1 2 499R 635-0069
MMBTA13
2 NPN 1% 0.1W
0.1W 49.9K 1% R164 J10 J17 OVLD LED1
PGND SYNC 1PB4/ARTCLK IC7A PB3/PWM0
42 PB3 D
2 1 1 2
2 2
LINE_SENSE 2PD0/AIN0 PB2/PWM1
41 PB2
359-0117A RED
DCBUS_VSENSE 3PD1/AIN1 PB1/PWM2
40 PB1 499R 635-0069
ST72324B 1% 0.1W
VBATT 4PD2/AIN2 39 BEEPER
CHRG_PUMP_OSC
PB0/PWM3
R125 J10 J17 LED4
4/A1 I_LOAD 5PD3/AIN3 PE1/RDI
38 SERIAL_IN 1 1
2 1
ON 1LINE 2
R81 7 7
TEMP 6PD4/AIN4 PE0/TDO
37 SERIAL_OUT C37
10.0K .01UF GRN
7PD5/AIN5
POW_SWITCH/XL_DETECT VDD_2
36 +5VS 150_OHM 635-0069
0.1W 50V 1% 0.1W
+5VS 8VAREF OSC1
35 OSCIN 10%
DGND 9VSSA 34 OSCOUT
1%
2
R124 J10 J17
1 OSC2 2 8 8
2 1
FAN 10PF0/MCO/AIN8 33 DGND
C91 VSS_2

.01UF CHRG_PUMP_OSC 11PF1/BEEP RESET

32 RESET 20K 635-0069
50V SS_LOWBAT 12PF2 31 VPP D D 1% 0.1W
VPP 1 1 1 1 1 1
10% TRIM 13PF4/OC1A/AIN10 30 ON_LINE
2
PA7/SCLI C67 C65 C66 C63 C57 C68
INV_ENA 14PF6/ICAP1A 29 REPLACE_BATTERY .01UF .01UF .01UF .01UF .01UF .01UF
C CHARGER_ENABLE 15PF7/EXTCLKA
PA6/SDAI

PA5
28 OVERLOAD 50V 50V 50V 50V 50V 50V C
D XFER_RELAY 16PC0/OC2B/AIN12 27 ON_BATTERY 10% 10% 10% 10% 10% 10%
PA4
2 2 2 2 2 2
RTH_L 17PC1/OC1B/AIN13 VSS_1
26 DGND
RTH_U 18PC2/ICAP2B VDD_1
25 +5VS
PHASE1_L 19PC3/ICAP1B 24 BOOST
PA3 D D D D D D
PHASE2_U 20PC4/MISO/ICCDATA PC7/SS/AIN15
23 XCAP
PHASE2_L 21PC5/MOSI/AIN14 22 PHASE1_U COLDBOOT
PC6/SCK/ICCCLK 4/B4
OVERLOAD
4/B4

+5VISO 8 J8 6 J8 7 J8
10PIN 10PIN 10PIN B6
ST_USB_VCC_IN TP2
722-0003 722-0003 722-0003
1 2 1 J15 USB_VCC 1
1 R181 10PIN
C2 ST_USB_SHLD 4
1 1 1 2
600_OHM_100MHZ 750-0031 J15 USB_SHLD
1000PF R3 R184 2 2
FERRITE 1
10PIN
1.0K 1 1
16V 2K 1.0K 1 C99 C109 BGND R38 750-0031
1 10% 0.1W 0.1W
D42 D53 0.1W 1% C100 33PF 0.1UF
2
3
339-0008 3
339-0008 0.1UF 0_OHM
R11 2 1% 1% 50V 50V
4148SE 4148SE 50V 0.1W
2K 2 2 1
Q44 1
75V 75V
10%
1
2
10% 10%
2 NA%
0.1W
D PNP 1 1 2 R176 2
1% D52 T2907A
BGND BGND Y3 1.0M_OHM
BGND
2 D4148CC 60V 3 BGND 0.1W
BGND
IC21 75V 24MHZ
1
4 1 SHUTDOWN_TXD 1% C98 B7
IC18 2
33PF D
D 3 2
3
8 USB_RESET
2
50V
1 USB_D+1 2 D+ 10 J15 D+
R1 NRESET R169 10PIN 9 J8
1 2 12 3 USB_OSCIN 10% 1.0K
349-0100 VPP/TEST OSCIN 2
600_OHM_100MHZ 750-0031 10PIN
+5VISO BGND 1 2 R182 BGND 30 2 USB_OSCOUT 0.1W 722-0003
1 2 10.0K
34
VSSA
72T63B OSCOUT
33 USBPOWER
FERRITE
D 0.1W 1% 1%
10
VDDA USBPOWER
31 2
10 J8
200_OHM PB7/AIN7/IT8 USBDP R42 10PIN
1 0.1W 1% 11 32 1 2

R8 R185 PB6/AIN6/IT7 USBDM B8 722-0003

1 2 USB_PB6 13
PB5/AIN5/IT6 PA0/CPUCLK
29 R40 0.1W 47.5R 1%
200_OHM USB_D-
14 28 1 2 1 2 D- 9 J15 D-
0.1W 20K 15
PB4/AIN4/IT5 PA1/SDA
24 ST_USB_VCC 10PIN 1 J8
1% 0.1W 1% PB3/AIN3 PA2/SCL 47.5R 750-0031 10PIN
2
IC20 1 16
PB2/AIN2 PA3/EXTCLK
23 0.1W 1% 2 2
600_OHM_100MHZ
722-0003
1 4 ONBATT_RXD R179 17 22 1
1 3
FERRITE
1.0K R4 PB1/AIN1 PA4/ICAP1/IT1 C84 C86 D40 3 J8
1 2 18
PB0/AIN0 PA5/ICAP2/IT2
21 0.1UF 3 4.7UF D39
2 3 0.1W 3 10PIN
5 20 50V 25V 339-0009
PC2/USBOE PA6/OCMP1/IT3 722-0003
1% 2K 6 19 D41 20% 6.2V BAT54S
349-0100 BGND 2 R178 0.1W 1% PC1/TD0 PA7/OCMP2/IT4 10% 2 0.35W 30V 5 J8
1 1 2 USB_PC0 7 1
2 339-0009 1 B5
PC0/RDI VDD BAT54S 1 5% ST_USB_GND_IN BGND 10PIN
R7 4 30V
1
1 2 7 J15
499R 20K VSS USB GND 722-0003
0.1W 1% 10PIN
0.1W BGND 750-0031
1% IC22 R183 359-7263B 600_OHM_100MHZ
FERRITE 5 J15
2 1 4 WAKE 1 2 3 J15 N/C
LOBATT 10PIN 05 CHANGES DOCUMENTED IN PCB REVISIONS dB. GWL P/R/C JD 09/04/03
10PIN 750-0031 04 CHANGES DOCUMENTED IN PCB REVISIONS dB. GWL P/R/C JD 07/01/03
200_OHM
2 3 0.1W 1% R180 750-0031
03 GWL JD 10/16/02
1 2 8 J15 INVSHUTDOWN
6 J15 CHANGES DOCUMENTED IN PCB REVISIONS dB. P/R/C

10PIN N/C 02 CHANGES DOCUMENTED IN PCB REVISIONS dB. GWL P/R/C JD 08/30/02
349-0100 BGND 10PIN
1 R46 R57 200_OHM 750-0031 01 CHRGR, LINE CORD DSCHRG, VAL CHNGS GWL P/R/C JD 05/10/02
D 750-0031
R17 1 2 1 2
0.1W 1% REV ECO DESCRIPTION DWN CHK APVL DATE
0_OHM BGND REVISIONS
0.1W 2K 49.9K DRAWN DATE
AMERICAN POWER
NA%
0.1W 1% 0.1W 1% NP/PJ/GL 04/24/02
E R18 IC1 2 R177 CHECKED
CONVERSION E
1/B6 ON_BATTERY1 2 1 4 1 2 2 J15 ONBATT
10PIN ENGINEER SCHEMATIC
200_OHM
0.1W
499R
1% 2 3 0.1W 1%
750-0031 NP/DR/MC 04/24/02
TITLE:
2 J8 ENG.MGR.
BGND 10PIN
349-0100
722-0003
JD 04/24/02
MODEL#:
D QUALITY:
SIZE
4 J8 REV

4 E 0S- 640-0253E 05
NOTE: ALL VALUES ARE FOR REFERENCE ONLY. SEE BOM FOR ACTUAL VALUES AND POPULATIONS. 10PIN PRODUCTION B
722-0003 SCALE: NONE
FILE NAME:
640-0253E_REV05 SHEET 1 OF 4

1 2 3 4 5 6 7 9-4-2003_14:42
8
 1 2 3 4 5 6 7 8

J13 OR J13A AVR BOOST BLK

E
SIZE
AVR HOT RED
RY1A

B
5 NC1
J14 J13 J13A
J29 8 NC2 2 2 2
2 4 NO1
COM1 3
J9 1 1 1 ORG
1 SURGE OUT COM2 7 2
UPS OUT
6 NO2
1 RY3 701-0013 701-0013 RY2 701-0013
J27 701-0013 RED
2 4 4
2 B A 1 701-0013 NC NC
BAT_BACKED_HOT
J20
1 3 COM COM 3 2
1 NO 5 5 NO
701-0013 1
450-0012A

REV
1
C101 24VBATT 701-0013
LINE IN INV_HOT 7 NC2
24VBATT 1 A B 2 2 B A 1 1
4700PF
BRN MV5 3/A8 6 450-0067 450-0067 C92
A 250V 5 NO2
COM2

D33 4700PF A
230V_90J 20% 250V
2
1
2
RY1 1 3
R22 NC1 20%
GROUND 100K
4 NO1
COM1 3
27V 3
2

1 2
GRN 1/4W ? .35W D34 1
C88A 1 5% 339-0083 D4148CC
1UF 420-0127
J31 2
8 B A 1 75V
2 450-0068 2 1
250VDC 2MH/15A
10% 1 4
1 1 MV7
2 C90 MV4 3 1 2 150V_90J
701-0013 R146 CHGND
0.47UF 230V_90J BOOST Q39 75V 3
1
1 1/B4 2 1 1 7.5_OHM 4148CA R145 Q38
2 3
250VAC CHGND TRIM
C88 L3 R24 60V D1 1/B3
1 2 1 7.5_OHM
0.47UF 20% 100K 10.0K 2 2N7002A 3 60V 2
2
250VAC 2
1% 0.1W 10.0K 2 2N7002A
1/4W
20% INV_NUTRL
5 NC1
RY1B 1
1 0.1W 1%
2
1 5% 8 NC2 3 R29
1 2 3/B8 COM1 3 R25 Q8 R36
C90A 1 4 NO1 150_OHM
PGND1
1UF C102 COM2 7 2 1 1 7.5_OHM 0_OHM
0.1W
4700PF 6 NO2 60V 0.1W
250VDC
10.0K 2N7002A 1%
10% MV6 250V 1% 0.1W
2
NA% 2
NEUT IN 2
230V_90J 20%
2 B A 1 2 AVR_LED 1/B7
BLU 2
1

J28
450-0012A PGND1 C29
2 2
4 .01UF
3
1 50V
3 D4
D30 1 I_LIMIT 1/A8 10%
701-0013 24VBATT D4148CC
2 SURGE NEUT D4148CC 75V 2

J30 YEL 1
75V
2 1 R69
1 1 2 I_LOAD 1/B2
C73 1 2
D
701-0013 10UF
2 1.0K
35V
20%
1 D31 3 3
1
0.1W 1%
1
C93 B
B 1
2 R141
1 3 3 460-0009 WHT 4700PF
C72 10.0K
CT1 D3 D2 R6
0.1W 43V 43V
124R
AVR NEUT 250V
10UF
35V
2
1%
27V .35W
5%
.35W
5% 0.1W J22 2
20% VIO
R142 ? .35W NC NC 2
20% Q37 2 339-0083
2 1 2 1 1% 2
UPS NEUT
2 1 2 1 1
R187 R170 PNP

IT BE USED FOR ANY PURPOSE WITOUT THE EXPRESS WRITTEN CONSENT bOF AN AUTHORIZED AGENT OF AMERICAN POWER CONVERSION COMPANY.
AMERICAN POWER CONVERSION COMPANY. IT MAY NOT BE COPIED OR USE D IN ANY MANNER NOR MAY ANY OF THE INFORMATION IN OR UPON

NOTICE OF PROPRIETARY PROPERTY: THIS DOCUMENT AND THE INFORMATIO N CONTAINED IN IT ARE THE PROPRIETARY PROPERTY OF
1 2 1 2 T2907A
701-0013
J21
20K 2
60V D
3 1% 0.1W
12K 12K BAT_BACKED_NUTRL 1
1/4W 5% 1/4W 5% R144 3
701-0013
1 1/B4 XFER_RELAY 1 2 1 Q36
CHGND 1
R171 MOSFET
2 R143 1.0K 3
2N7002A
2M
10.0K 0.1W 1%
2 R84 R85 R2
1/8W D44 7.5_OHM 1 2 1 2 1 2 LINE_SENSE 1/B3
D4006 0.1W D32
5% 13V PGND1
2
BWF Circuit LED6
1A
800V 2
1%
1
0.35W
5%
+12V 1.0K
0.1W 1%
1.0K
0.1W 1% 369-0009
D18
3
1.0K
0.1W 1%
120V version only RED R76 C31
1
1 PGND1 2 1
LM358 D4148CC
R188 1 2 PGND1 2 1

2M 6
- 75V 1 2
21.5K
1/8W 1% 0.1W .01UF
D 8 10% 50V IC8 OUT
7
5% 3 R166 R139 R135 R131 D
2 EMI_OUT_NUTRL 1 2 1 2 1 2 1 2 3 5
+
1
3 +
1 C87 1
499K 499K 499K 499K
22UF D43 1/4W 1% 1/4W 1% 1/4W 1% 1/4W 1%
IC8 OUT D
1 16V 13V 2
R186 3 20% 1/2W R167 R140 R136 R132 -
D45 Q43 2 5% EMI_OUT_HOT
200K
NPN 1
1 2 1 2 1 2 1 2
4 LM358 +5VS
D4148CC 369-0009
0.1W MMBTA13 2
1 2 75V 499K 499K 499K 499K C30
1% 1/4W 1% 1/4W 1% 1/4W 1% 1/4W 1%
C 2
2 1

1 C
.01UF R96
10% 50V D 1 10.0K
R75 -8V
1 2 R95 0.1W
10.0K 1%
21.5K 3 0.1W 2 SYNC
0.1W 1% D16 1/B3
1%
L5 D4148CC 2
3
1 2 75V 1 C34
1 2 Q24
47UH/3A 1 NPN 1000PF
420-0126 2N2222 16V
C85 C83 600MA_75V
L4 R39 F4 10%
2 2
1 2 1 2
2 1 1 2 1 2

47UH/3A
420-0126 1R6 J1 1NF 1NF
2 1.6A_250VAC D
2W 5% 250V 20% 250V 20% D
1 F4A T2
5 8 D35 R155
701-0013 1 2
1 2 1 2 WAKE_UP
4/B4
3A_250VAC 49.9K
339-0008 3
4148SE 0.1W 1%
75V 24VBATTA 24VBATT
C78 L6
R156 L7
1
1 1 1 2 1 2 2 3 1 2
R175 1 4 6
1 C95 R174 R34 IC17 1 10UH/2A
1.0M 24R 420-0128
D50 4.7NF 47K 47K
1W 5%
100PF
4 1 R147
1/4W 1 500V 10% 1 4
1000V 500V 1W 1W 1.0K
1.5A 1% 10% 5% 5% 0.1W 750 OHMS/2A
2
S2M 2 851-1721 2 D36 3 2 429-0002
D
D 1
1 HS9
2 2
2 1
2
1%
R152 F
D48 349-0108 1 2
1000V
R173 200V
390K 1 2 3 4 50NS 5A 1
1.5A 1 2.32K
S2M 2
1/4W R19 1
1/2W 1% 3
D49 1 1 R153
5% 1 10R Q27 R87
600V
C79 R73 R37 1.5K NPN 1 CHARGER_ENABLE
2 R172 1A 2 430-0183
1/8W
200.0R 200.0R
1 2
1/B3
2 560UF 1W 2N2222
1 2 75NS 5% 1
1 35V 1/8W 1/8W 600MA_75V 2K
R30 20%
2 5% R88
15K 3 SHIELD 2 1% 1% 2 R32 2 2K
0.1W 1%
499K 1
0.1W 1% C15 2 2 1 2
0.1W
1/4W 3 5 T2A 8 .47UF 1
1
1% X (M)
16V
20K 1
C75 R150 R33 1%
2 D7 0.1W 1%
0.1UF 20K 2M
2
10%
5
F
IC19 2
3 4 1 50V .06W 1/8W
360-0035 4 .25%
TOP246Y S A2 NC1 K 10% 5% D
369-0061 2 2
2
.5% 8
1
2 6 C80 TL431 REF
L (N/C2) N/C6
D47 1 2 IC16
NC2 A3 A4 A1
1000V
1.5A C 4 6 3 4.7UF 5 6 7 2
R151
2 1 Q41 35V 20% 1 2
S2M
D38 NPN 1
1 1
1 2 SMBT3904 2K
3
D46 1 600MA_75V .06W .25%
1 200V 3 Q40 R148
1000V
R168 R21 1A 50NS 2 D54 NPN 1 1 2
1.5A 4.7 4148CC
S2M 2 6.8_OHM 2N2222 1
1/2W 75V 600MA_75V 10.0K 1
0.1W 1 2 R149 1/8W 1%
C74 REV ECO DESCRIPTION DWN CHK APVL DATE
5% 5% 2 49.9K 0.1UF
2 REVISIONS
1 2
1 1 1 0.1W 50V
C96 R31 R158 R157
DRAWN DATE
AMERICAN POWER
82UF 1 1% 10% NP/PJ/GL 04/24/02
E 450V C94
1
C82 2 430-0184 1.2_OHM 1.2_OHM 49.9R 2
2
CHECKED
CONVERSION E
20% 47UF 0.1UF 1W 1W 0.1W
2 16V 100V 3 SHIELD 5% 5% 1%
R20 ENGINEER SCHEMATIC
20%
2
2
10% 2 2 2
1 2 NP/DR/MC 04/24/02
TITLE:
ENG.MGR.
.33_OHM
1W 5%
JD 04/24/02
MODEL#:
QUALITY:
SIZE REV

E 0S- 640-0253E
NOTE: ALL VALUES ARE FOR REFERENCE ONLY. SEE BOM FOR ACTUAL VALUES AND POPULATIONS. PRODUCTION 4 B 05
SCALE: NONE
FILE NAME:
640-0253E_REV05 SHEET 2 OF 4

1 2 3 4 5 6 7 9-4-2003_14:42 8
 1 2 3 4 5 6 7 8

E
SIZE
B
B1
R90 R53 R51
DCBUS_VSENSE 1 2 1 2 1 2 DCBUS+A DCBUS+
1/B1 2 1

332.0K 332.0K 332.0K

REV
1 1 1 1
1/8W 1% 1/8W 1% 1/8W 1% 550 OHM/100MHZ
2 C119 2 C120 2 C121 C28
FERRITE
Q5 10NF Q1 10NF Q3 10NF 10UF
1 2 3 4
1 0.18_OHM 1 0.18_OHM 1 0.18_OHM
500V 500V 500V
A R91 R54 R52
200V 200V 200V 450V
HS6 A
DCBUS_OVP
1 PWR 20% D207 1 PWR 20% 1 PWR 20% 20%
3/D6
1 2 1 2 1 2
D210 2 1 R232 3 2 2 1 R229 3 2 3 2 2

R60 75V
R61 2 1
R227 R62 870-1461
D4148CC 4.99K D4148CC 4.99K 75V 4.99K
332.0K 332.0K 332.0K 1 2 1 2
1 2

1/8W 1% 1/8W 1% 1/8W 1% 75V 0.1W 0.1W D4148CC 0.1W JGND

3
3 1% 0.1W 100K 1% L1A 1% 0.1W 100K 1% D206 1%
0.1W 100K 1%
2 2 3
1 3 2

2MH/1.7A
L2
L1
420-0052B 1 2 INV_HOT 2/A3
1 3 38UH/12A 2
420-0018 2

PRI_B 8 T1A 15 +12V 650UH/4.5A 5% 20% J11

3/B1 BATT+ 420-0098 2
3/C5,3/B1, 1/2W 500V
9 16 D209 +12V 1
2 1 1 1 4.7 10NF
1/2W 5%
1 1
1 D208 R230 R255 R104 C81 701-0013
C25 1 800V R233 R256 2 1 4.7
1
1

4700PF 100K100_OHM INV_NUTRL

C3 D4006 1A 100K 100_OHM 1 2
2/B3
250V 800V 0.1W 0.1W
22UF 0.1W 0.1W 1
16V 1 D4006 1A C214 1% 1% R99
20% C216 1% 1% 2.2UF 2 2
2 20% 1
BATT+ 6 2.2UF 2 2
3/C5,3/B1,3/A3 2
1 16V C104
7
16V C103 10% 1000PF
10%
C5 JGND
1000PF 8 2 16V +12V
R13 2
16V VB
10% 1 1
12 8 PHASE1_U 2 7 PHASE1_UG D205
1 2 1 2 870-1461 10% 1/B4 HIN HO 2 R228 R250
13 RTH_U VB 2 6 2 1
2 7 RTH_HG VS 100K 100_OHM
24R 470PF
HS4 1/B4 HIN HO PHASE2_L 3
1W 5% 6 1/B4 LIN 800V 0.1W 0.1W
500V 10%
RTH_L
VS IC204 D4006 1A C213 1
1% 1%
D13 1 2 3 4 1/B4,3/E6 3 LIN 369-0028 2.2UF 2 2
SEC_B 3 1 C48 IC205 IR2101S PHASE2_LG
1

470PF 369-0028 LO
5 PHASE2_U
16V C105
50NS 200V 1 1 +VC 1/B4 10% 1000PF
8A C110 50V IR2101S RTH_LG 3/B6,3/B3 1 VCC
5 PHASE1_L 2 16V
10 17 C8 470PF LO
GND 1/B4 B
R16 50V
10% 1 8 10%
B 3/C4,3/C1 PRI_A 11 18 1 2 1 2
1 VCC
GND Q6 1 1
4
D220 SP3 3/B3,3/B4
+VC
2
VB
7 PHASE2_UG
2
10% C50 HIN HO
430-0156
24R
R48 2 2 4 0.18_OHM
470PF
2 1 1 2

6
470PF 47K 200V VS
1W 5% 500V 10% D222 50V 400V
Q2 3
1W PWR 1 0.18_OHM LIN
PRI_B 9 T1 19 5% +12V 2 1 2 C122 C111 ES1G 1A IC203
3/A1 SEC_A D14 R254 10%
0.1W 1% 200V 1 1
10 20
2
1 2 10NF 2 2
PWR
2 C123 369-0028 2 C124
400V R247

IT BE USED FOR ANY PURPOSE WITOUT THE EXPRESS WRITTEN CONSENT bOF AN AUTHORIZED AGENT OF AMERICAN POWER CONVERSION COMPANY.
AMERICAN POWER CONVERSION COMPANY. IT MAY NOT BE COPIED OR USE D IN ANY MANNER NOR MAY ANY OF THE INFORMATION IN OR UPON

NOTICE OF PROPRIETARY PROPERTY: THIS DOCUMENT AND THE INFORMATIO N CONTAINED IN IT ARE THE PROPRIETARY PROPERTY OF
3 1 1 4.99K PHASE1_LG
ES1G 1A 500V 470PF 10NF IR2101S Q4 10NF
11 50NS 200V 1 1 50V 1
LO
5 1 2 1 0.18_OHM
8A 4.99K 20% 500V 500V
C9 C9B R9 0.1W 1% 2
3 2 10% 1 2 1 VCC
200V
22UF 68UF
1 2
1% R65 R249 2
3 2
20%
GND
0.1W 4.99K 1% 2
3
PWR 2
20%
1% 1%
400V 400V 1 +VC 0.1W 1 2 R64 1 1 4 R63
C7 20% 20% 20_OHM 0.1W C112 C52 0.1W 1 2
3/C5,3/B1,3/A3 BATT+ 6 R15 2 2 0.1W 1% 100_OHM 0.1W 100K 1% 100_OHM
1 2
470PF 470PF
D217 100_OHM
1 2 1 2 R23 3/B6,3/B4 2 1
7 R246 0.1W 100K 1%
47K 1
R248 0.1W 100K 1% 50V 50V R257
8 24R 1W 1 1
10% 10% 400V 75V 1
470PF 2 2 ES1G 1A
1W 5% 5% C218 1 1 D4148CC
500V 10% 2 1
15 D8 .01UF 3
C217 3 1
16 1 3
50V 4.7UF 2
10% 2 25V 3
17 200V 50NS 2 D221 20% D219 1
2
8A D4148CC 2 D4148CC C215
75V 1
1
75V .01UF D216
C6 1
1 C107 R245 50V 1
R14 C108 R253 1
1 2 1 2 1000PF
1000PF 100K 10% C106 R244
100K 16V 0.1W 1000PF 100K
12
16V 0.1W 2
13 21 24R 470PF 10% 1% 16V 0.1W
1W 5% 10% 1% 2
2 1 2 3 4
PRI_A 14 22 500V 10% 2 10% 1%
3/C4,3/B1 B2 2 2
2
D9
430-0155 1 3 JGNDA 2 1
HS3
200V 50NS 870-1461
1 1 2 3 4
8A C18 JGND
550 OHM/100MHZ
4700PF R100 R102 R105
C HS1 FERRITE Q2_SENSE
250V
870-1461
1 2 1 2 1 2 3/D6 C
20% 332.0K 332.0K 332.0K
2
1/8W 1% 1/8W 1% 1/8W 1%
PGND 24VBATT
870-1461
F2
HS5
+12V 2 1

1 2 3 4 PRI_A
1A_125V 880-1011 +5VS
3/B1,3/C1
2
1 R56 Q14 1 2 3 4
BJ1
BB1
R159
2 1

1 2 1 50V 1
1 PP_ENA
B3 0.008_OHM 1 2 3 4 5 6 R160 2 1
4.7_OHM 3
HS2 3/B1,,3/A3 1/B8
600_OHM_100MHZ R66 PWR R55 1 10.0K
0.1W 5%
10_OHM
870-1461 200K +12V
IC5 FERRITE 1 2 0.1W
1% 0.1W
1/4W R26 1%
2 5% 10_OHM
1 NC1 NC2
8
R27
0.1W 10.0K 1%
2 2
Q7 1/4W F1 J7 RED BATT+ 2
3 1
2
DC-DC_OUTA
2 INA 7 5%
3 4
BATT + R117
1/A8 OUTA
1 2 1 50V 2 1 2 1 1
C44 IC13
3 GND 6 1 4.7_OHM 1
0.008_OHM
40A_32VDC 517-1040 701-0013 POS (+) OUT 4.99K
C69 1 VDD 1 C26 3 PWR 2 1 3/A1
DCBUS_OVP 2 0.1W
3
R28 0.1W 5%
0.0022UF
R67 - LM393 1%
.01UF 4 INB 5 R126 D28 R120 Q42
OUTB 10.0K 1 2 C10 1
3300UF F3 J16 369-0004 INV_ENA 2
50V D10 0.1W
50V
0.0022UF 3 4 1 2 1 2 2 2 1 1 NPN
40V 10% 0.1W 10.0K 1% 20% 35V 1/B3 2N2222
10% 1% 2 50V 1 2
800V 1
2 1A 4.7 2K 600MA_75V
369-4427 2
2 C47 1A D4006 701-0013 1% 0.1W 1
10%
2
40A_32VDC 517-1040 2W 5% C58 2
PGND PGND 2 1 1000PF
C11 PGND
1 2 1 16V
1 3300UF 1
R94 C45 R59 1
10%
20% 35V R121 2
2.2UF 10.0K 0.0022UF 1 2
1
C62 13.3K
C60
D 16V 10% 0.1W 50V 0.0022UF 0.1W
.01UF
50V R12 D
10% 0.1W 10.0K 1% J6
C12 1% 2
3 PWR
50V
XL_BAT 2 1% 10% 1 2
2 R123 10% 1/B5 2 2 D
1 2 0.008_OHM 2 1
1 2 200K
1 50V 0.1W 1%
701-0013
PGND 0.1UF 4.7_OHM Q33
1
2 1 J3 +5VS
50V 10% 0.1W 5% 2 D +12V
R58 R122 1 C59
R92
1 2
10_OHM 10_OHM
IC10 1/4W 701-0013 1 2
1

0.1W 10.0K 1% 1/4W R118

5% 5%
1 NC1 NC2
8 3 PWR 2
2 J2 8 0.1UF 100K
R93 870-1461 2 50V 10% D 0.1W
DC-DC_OUTB 2 7 0.008_OHM Q2_SENSE
1/A8 OUTA
1 2
50V HS8 1 5
+
INA 1 3/C7 V+ 1%
1
3 6 1 4.7_OHM 2 Q28 701-0013 1 7
2
XCAP
C76 GND VDD
1 2 3 4 PGND IC13 OUT 1/B4
0.1W 5%
4 INB 5 PRI_B 1 1
J5 BLK R119
.01UF
4/B1 C14 C32 2 6 V-
-
OUTB
20K
D27
50V
40V 1 2 3 4
1NF 1NF
1 BATT 0.1W
LM393
369-0004
10% 250V 250V 1 2
1A
2
369-4427 2
20% 20% 701-0013 NEG (-) 1%
2
4 75V
D4148CC
HS7 2 2

PGND D26
C61 PGND 870-1461 3
1 2 D D
+5VS 1 1
C27 C33
2.2UF 1NF 1NF RTH_L
16V 10% 1/B4,3/B3
250V 250V
1
C46 20% 20%
2 2
1 2 TH1 REV ECO DESCRIPTION DWN CHK APVL DATE
T NTC
PGND 0.1UF 10K CHGND REVISIONS
DRAWN DATE
50V 10% 5% AMERICAN POWER
NP/PJ/GL 04/24/02
E 2
CHECKED
CONVERSION E
TEMP 1/B2
1 ENGINEER SCHEMATIC
R70 NP/DR/MC 04/24/02
TITLE:
4.99K ENG.MGR.
0.1W JD 04/24/02
MODEL#:
1% QUALITY:
2 SIZE REV

NOTE: ALL VALUES ARE FOR REFERENCE ONLY. SEE BOM FOR ACTUAL VALUES AND POPULATIONS. PRODUCTION
E
B 0S- 640-0253E 05
D SCALE: NONE
FILE NAME:
640-0253E_REV05 SHEET 3 OF 4
9-4-2003_14:43
1 2 3 4 5 6 7 8
 1 2 3 4 5 6 7 8

E
SIZE
B
24VBATT

+12V +12V

2
SP2
1
24VBATT2 2 J12
1 3 1 2PIN
-8V

REV
R83 R98 715-0013
Q25 Q29
10.0K 1 NPN 20K 3
PNP 1 2
0.1W 2N2222 0.1W R128 Q35 75V
A 600MA_75V
T2907A
2 1/B3 FAN 1 2
1 NPN D4148CC A
1% 1% 60V 2N2222 24VBATT
2 2
1
2 D29
C40 2 20% 1 2K 600MA_75V 3
D21 16V +24V
+12V 0.1W 1% 2
1 2 4148SE 22UF 1 C71
3 75V R101 B4 1 2 1 J12
3 3
3 22UF C41 2K +24V2 IC11 2PIN
R86 Q26 16V 20% 1
1 2
369-0112
CHRG_PUMP_OSC1 2 1 NPN 2 0.1W 1 VIN VOUT
3 PGND1 0.1UF 1 715-0013
1/C2 50V 10% C70
2N2222 1% 600_OHM_100MHZ
10.0K 1% 600MA_75V PGND GND 1
1 10UF
1 2 2
FERRITE 4
C53 C4 35V
0.1W 2 D 1 1 0.1UF 22UF 20%
R103 1
C49 50V 16V 2
PGND D19 2K 10UF 20%
D4148CC
R97 35V D
10%
2
2
0.1W PGND1
75V 20K 20%
1% 0.1W 2
2
1%
2 D D
3
D
Q30 1
NPN
2N2222 1

600MA_75V R106
2
10.0K
1 1 1 1 1 1 1 1
0.1W
D 1% R107
2 2 1
F301 F302 F303 F304 F305 F306 F307 F308
WAKE_UP
2/D7 100K
SP201 D 1% 0.1W 3 5A_125VAC 5A_125VAC 5A_125VAC 5A_125VAC 5A_125VAC 5A_125VAC 5A_125VAC 5A_125VAC
1 2 Q31
1 7.5_OHM
COLDBOOT
4 5 5 4
1/C7
2 1
60V
2N7002A
2 2 2 2 2 2 2 2
B
B F201
C54 R109
1 2

1 1 2 1
R108 D22 2M
C51
J201 J202 1/C7 OVERLOAD 1 2 1 2
3 0.1UF
339-0008 1/8W
727-0012 727-0012
4148SE 50V 1 1 1 1 1 1 1 1
4A_250V 1.0K 5% 10% D
1 1000PF 75V
3 2 2 3
16V 10% 0.1W 1% 2 2

F309 F310 F311 F312 F313 F314 F315 F316

IT BE USED FOR ANY PURPOSE WITOUT THE EXPRESS WRITTEN CONSENT bOF AN AUTHORIZED AGENT OF AMERICAN POWER CONVERSION COMPANY.
AMERICAN POWER CONVERSION COMPANY. IT MAY NOT BE COPIED OR USE D IN ANY MANNER NOR MAY ANY OF THE INFORMATION IN OR UPON

NOTICE OF PROPRIETARY PROPERTY: THIS DOCUMENT AND THE INFORMATIO N CONTAINED IN IT ARE THE PROPRIETARY PROPERTY OF
1
B201
180_OHM/5A D D
X201 X203
410-0017 D 5A_125VAC 5A_125VAC 5A_125VAC 5A_125VAC 5A_125VAC 5A_125VAC 5A_125VAC 5A_125VAC
1 1
2 2 2
2 2 2 2 2 2 2 2

SLOT30X120P SLOT30X120P
X202 2 X204
1 1
2 D201 2
368-0028 SLOT30X120P
SLOT30X120P 1.5KW
28V
2
J203
1

9
1
701-0013

MTG1
CHGND3

MTG1
2

2
1

1
3

3
J301

J302
5

5
4

4
6

6
C C

8
7

7
MTG2

MTG2
10

10
1 1 1 1 1 1 1 1

D316 D315 D314 D312 D309 D317 D318 D301

2 D4006 2 D4006 2 D4006 2 D4006 2 D4006 2 D4006 2 D4006 2 D4006 800V 800V 800V 800V 800V 800V 800V 800V
1A 1A 1A 1A 1A 1A 1A 1A 1A 1A 1A 1A 1A 1A 1A 1A
2 2 2 2 2 2 2 2
800V 800V 800V 800V 800V 800V 800V 800V D4006 D4006 D4006 D4006 D4006 D4006 D4006 D4006
D303 D304 D305 D306 D307 D308 D310 D311
1 1 1 1 1 1 1 1
PTC5
J26 2 TIP1 1 2 3 J24
6POS/4TERM 6POS/4TERM
750-0024 750-0024
160-R376 1
15_OHM Q301
2
J38
1 1 2
MV11 1
320V 1 701-0013
313-0001
MV12
175V_35J 2 D4006
1
2 MV13 1A
D313 800V
320V SG1
2 CHGND1 800V D302 1 2
1A 1
SPARKGAP_1500V
D
2
D4006 D
GDT301
PTC6 2
J303
1 2 2
J26 3 RING1 2 J24 1 2

6POS/4TERM 6POS/4TERM 1
750-0024 750-0024 2500V 701-0013
160-R376
15_OHM J25
CHGND2
1 3

2 4
870-1975

CHGND1

MTG4 MTG5
MTG1 MTG2 MTG3

MTG063NP MTG063NP
X2 X3
MTG150NP MTG150NP MTG150NP 0.125_NP 0.125_NP X8 X9 X10 X11 X12 X13
MTG6 MTG7

MTG063NP MTG063NP
X4 X6 X19 X25 X26 SLOT SLOT SLOT SLOT SLOT SLOT
MTG8 MTG9 SLOT30X50SLOT30X50SLOT30X50 SLOT30X50SLOT30X50SLOT30X50 REV ECO DESCRIPTION DWN CHK APVL DATE
0.125_NP 0.125_NP 0.125_NP 0.125_NP 0.125_NP
REVISIONS
X14 X15 X16 X23 X24
DRAWN DATE
AMERICAN POWER
MTG063NP MTG063NP
NP/PJ/GL 04/24/02
2

E E
BJ4

BJ3

BJ5
MTG10 MTG11
CHECKED
CONVERSION
X27 X28 X18 X7 X1
1

SLOT SLOT SLOT SLOT SLOT

SCHEMATIC
1 2

0.125_NP 0.125_NP FIDUCIALG FIDUCIALG FIDUCIALG SLOT30X50SLOT30X50SLOT30X50SLOT30X50SLOT30X50 ENGINEER

BJ6 MTG063NP MTG063NP

MTG12
NP/DR/MC 04/24/02
TITLE:
1 2
X5
ENG.MGR.
X17 X22 JD 04/24/02
MODEL#:
JGND PGND PGND1 MTG063NP 1 2 1 2 QUALITY:
D F X20 X21 SLOT SIZE REV

NOTE: ALL VALUES ARE FOR REFERENCE ONLY. SEE BOM FOR ACTUAL VALUES AND POPULATIONS.
10mOHM_2_OZ_PRI
10mOHM_2_OZ_SEC BOWTIE BOWTIE SLOT62X1200
PRODUCTION
E
B 0S- 640-0253E 05
SCALE: NONE
FILE NAME: 640-0253E_REV05 SHEET 4 OF 4

9-4-2003_14:43
1 2 3 4 5 6 7 8
Back-UPS RS 1500VA Page 1 of 3

Back-UPS RS 1500VA
Part Number : BR1500

Product Overview
APC Back-UPS RS, 1500VA/865W, Input 120V/ Output
Description
115V, Interface Port USB, Extended runtime model
Audible Alarms, Automatic Self Test, Automatic
Shutdown, Automatic Voltage Regulation (AVR), Building
wiring fault indicator, Cold-start, Easy Overload Recovery,
Hot Swap Batteries, Intelligent Battery Management,
Internet FAX - modem - DSL surge protection, Lightning
Features
and Surge Protection, Overload Indicator, PC and Mac
Compatible, Replace Batt Indicator, Resettable circuit
breaker, Software, Status Indicator LED's, Transformer
Block Spacing, Unattended Safe & Graceful Shutdown,
USB Connectivity, User Replaceable batteries
CD with software, Free trial of anti-virus : firewall : email
privacy : system recovery and online backup software,
Includes
USB cable, User Manual, Velcro Cord Management
Straps

Options
Optional Service Click here to view optional Service.

Documentation
Back-UPS RS - 1000, 1500; User Manual Back-UPS
User Manual & Installation Guides
XS - 1000, 1500; User Manual

Communications & Management

Interface port USB
LED status display with On Line : On Battery : Replace
Control panel
Battery and Overload indicators

08/06/2003
Back-UPS RS 1500VA Page 2 of 3

Alarm when on battery : distinctive low battery alarm :

Audible alarm
configurable delays
Included Software APC PowerChute Personal Edition

Output
Output power capacity 1,500 VA
Output power capacity 865 Watts
Max Configurable Power 1,500 VA
Max Configurable Power 865 Watts
Nominal output voltage 120 V

(6)NEMA 5-15R
Output Connections
(2)NEMA 5-15R (Surge)

Input
Nominal input voltage 120 V
Input frequency 47-63

Input Connection Type NEMA 5-15P

Cord Length 6 feet (1.83 meters )

Input voltage range for main operations 88 - 148 V
Input voltage adjustable range for main operations 78 - 152 V

Surge Protection and Filtering

Surge energy rating 420 joules
Full time multi-pole noise filtering : 5% IEEE surge let-
Filtering
through : zero clamping response time : meets UL 1449
RJ-11 Modem/Fax/DSL protection (two wire single line),
Dataline protection
RJ45 10 Base-T Ethernet protection

Runtime
Typical backup time
12.4 minutes (432.5 Watts)
at half load
Typical backup time
3.7 minutes (865 Watts)
at full load
Runtime Chart Back-UPS RS

Batteries
Maintenance-free sealed Lead-Acid battery with
Battery type
suspended electrolyte : leakproof
Replacement battery cartridge (1) RBC33
Extended run options for Back-UPS RS 1500VA

08/06/2003
Back-UPS RS 1500VA Page 3 of 3

Physical
Maximum height dimensions 14.60 inches ( 37.08 cm)
Maximum width dimensions 3.40 inches ( 8.64 cm)
Maximum depth dimensions 13.10 inches ( 33.27 cm)
Net weight 25.00 lbs ( 11.36 kg)
Shipping Weight 26.00 lbs ( 11.82 kg)
Shipping Height 17.90 inches ( 45.47 cm)
Shipping Width 8.00 inches ( 20.32 cm)
Shipping Depth 16.40 inches ( 41.66 cm)
SCC Codes 1073130419314 9
Color Beige
UPC Code 731304193142

Environmental
Operating Environment 0 - 40 °C (32 - 104°F)
Operating Relative Humidity 0 - 95%
Operating Elevation 0-10000 feet (0-3000 m)
Storage Temperature -5 - 45 °C (23 - 113°F)
Storage Relative Humidity 0 - 95% Non-condensing
Storage Elevation 0-50000 feet (0-15000 m)
Online thermal dissipation 180 BTU/hr

Conformance
cUL Listed, FCC Part 15 Class B, FCC Part 68, UL 1449,
Approvals
UL 1778, UL Listed
Standard warranty 2 years repair or replace
Equipment protection policy Lifetime : $150000

* Without TAX/VAT

08/06/2003