TRANSMISSION

2.2L VIN H

HOT AT HOT IN RUN HOT IN HOT IN OFF, HOT IN RUN

ALL TIMES OR START RUN RUN, OR START OR START
UNDERHOOD I/P FUSE (UNDER DASH,
FUSE BLOCK ABS CLSTR GAUGES BLOCK ON HEATER
ECM B ECM I
(ON TOP OF FUSE 22 FUSE 11 FUSE 4 (ON LEFT CASE)
FUSE FUSE
LEFT FRONT 10A 10A 10A END OF BODY CONTROL
20A 15A
FENDER) DASH) MODULE
PNK B2
A8 A10 C2
C1

BRN

PNK

PNK

PNK
ANTI-LOCK
ORG

PNK

PNK
BRAKES
A7 YEL A1
SYSTEM S129
INSTRUMENT C2

PNK
PNK
PANEL
BRN
PPL

FUEL INSTRUMENT CLUSTER

COMPOSITION CLUSTER SOLID (IPC) LT GRN A12
BRN SENSOR STATE C1
D
BRN
MIL LT GRN M
(BODY HARN, NEAR (SERVICE
BREAKOUT TO BLOWER ENGINE
C PPL MOTOR RESISTOR) SOON IND) DK GRN B
S138
PPL PPL
STOPLIGHT A11
SWITCH PPL A

BRN/WHT
(ON BRAKE
PEDAL CRUISE SPLICE PACK
SUPPORT CONTROL SP201
BRACKET) SYSTEM (BEHIND
LEFT SIDE
35 420 OF DASH)
PPL
BRAKE SW IN
20 ORG 440 PPL 2 DATA LINK
BATTERY
19 PNK 439 CONNECTOR
IGN (UNDER
61 PNK 1020 LEFT SIDE
IGN IN
58 YEL 710 OF DASH)
SERIAL DATA II
59 DK GRN 1049
SERIAL DATA II
57 BLK 452 BLK B
TP SENS GND
21 DK BLU 417 DK BLU C
TP SENS SIG
46 YEL/BLK 1227 GRY A
TFT SENS SIG
54 YEL 410
ECT SENS SIG
29 BLK/WHT 771 THROTTLE
TR SW-A IN POSITION
69 YEL 772
TR SW-B IN (TP) SENSOR
72 GRY 773 (ON THROTTLE
TR SW-C IN
73 WHT 776 BODY ASSEMBLY)
TR SW-P IN
28 RED 1226
TRANS RANGE-C
67 DK BLU 1225
TRANS RANGE-B
63 PPL/WHT 821 PPL/WHT A
VSS HI
68 PNK 1224
TRANS RANGE-A
18 BLK/WHT 351 LT GRN/BLK B
PCM GROUND
60 BLK/WHT 351 BLK/WHT
PCM GROUND G103
C1 S106 (RIGHT FRONT VEHICLE SPEED
OF ENGINE, SENSOR (VSS)
UNDER THE (ON RIGHT REAR
GENERATOR) OF TRANSMISSION)
BARE BLK
G105
64 BLK/WHT 351 (RIGHT REAR
PCM GROUND S140
46 BRN/WHT 419 OF ENGINE)
MIL IND CTRL
33 GRY 416 YEL B
TP SENS 5V
62 LT GRN/BLK 822
VSS LO
27 BRN 718 BRN A
ECT SENS GND
29 BLK 407
TFT SENS GND
50 TAN/BLK 422 ENGINE COOLANT
TCC SOL TEMPERATURE
51 YEL/BLK 1223
2-3 SS (ECT) SENSOR
52 WHT 687 (FRONT OF ENGINE,
3-2 SS
53 LT GRN 1222 IN COOLANT PIPING)
1-2 SS
57 BRN 418
TCC PWM
6 RED/BLK 1228
PC SOL HI
9 LT BLU/WHT 1229 BLK/WHT A
PC SOL LO
C2
A
POWERTRAIN CONTROL
MODULE (PCM) YEL D
(ON RIGHT FRONT
OF ENGINE COMPT)
B
GRY B

C
WHT C
LT BLU/WHT

C2
RED/BLK

TAN/BLK
YEL/BLK

P
DK BLU
LT GRN

L YEL/BLK
WHT

PNK

PNK
BRN

RED

A
(NOT USED)
M BLK

BLK/WHT D P/N
U

N
D

R
T

P
S

AUTOMATIC C1
TRANSMISSION S152
BLK/WHT

PARK/NEUTRAL
B LT GRN
LT BLU

D ORG
C PNK

E BLU

(4L60-E)
POSITION SWITCH
DK
A WHT

RED
B TAN

B BLK

A BRN
B YEL

B GRY
A PPL

(ON LEFT SIDE OF

TRANSMISSION)
AUTOMATIC
TRANSMISSION G103
D3 D4 FLUID (RIGHT FRONT
PRESSURE OF ENGINE,
REV (TFP) MANUAL UNDER THE
VALVE GENERATOR)
POSITION
B

LO D2 SWITCH
RED RED RED RED RED TRANSMISSION
PRESSURE FLUID
CONTROL TCC 1-2 3-2 2-3 TCC TEMPERATURE
SOLENOID PWM SHIFT SHIFT SHIFT SOL SENSOR
VALVE SOL SOL SOL SOL
152470
2.2L VIN H, A/T Wiring Diagram, 4L60-E

4.3L VIN W

HOT IN RUN HOT AT HOT IN HOT IN OFF, HOT IN RUN

OR START ALL TIMES RUN RUN, OR START OR START
UNDERHOOD I/P FUSE (UNDER DASH,
FUSE BLOCK ABS CLSTR GAUGES BLOCK ON HEATER
ECM I ECM B
(ON TOP OF FUSE 22 FUSE 11 FUSE 4 (ON LEFT CASE)
FUSE FUSE
LEFT FRONT 10A 10A 10A END OF BODY CONTROL
15A 20A
FENDER) DASH) MODULE
PNK B2
A10 A8 B8 C2 LT GRN A12
BRN PNK PNK PNK
C1
PNK ORG ORG UTILITY W/
FLOOR SHIFT A7
INSTRUMENT YEL A1
S203 S113 PANEL C2
CLUSTER
BRN BRN PNK PNK PNK SOLID (IPC)
D STATE LT GRN M
STOPLAMP DK GRN B
ELECTRONIC SWITCH A/T INSTRUMENT MIL PPL A
BRAKE (ON BRAKE SHIFT CLUSTER (SERVICE
CONTROL PEDAL LOCK ENGINE
MODULE SUPPORT SOLENOID SOON IND) SPLICE PACK
C BRACKET) SP201
(BEHIND
A11 LEFT SIDE
PPL OF DASH)
S138 BRN/
(BODY HARN, NEAR WHT PPL 2 DATA LINK
PPL PPL BREAKOUT TO CONNECTOR
BLOWER MOTOR (UNDER
RESISTOR) LEFT SIDE
OF DASH)
CRUISE
CONTROL &
ANTI-LOCK A/T FLUID
BRAKES PRESSURE
1 BLK/WHT 351
GND SYSTEMS MANUAL VALVE
8 GRY 416 POSITION SWITCH
+5V
17 DK BLU 1225 DK BLU R DK BLU E
RANGE B D3, D2
18 RED 1226 RED P ORG D
RANGE C D4, D2
19 PNK 439 PNK N PNK C
IGN REV, LO
20 ORG 440
B+
32 BLK/WHT 771
PRND A
33 PPL 420
BRK SW
34 WHT 776
PRND P FLUID TEMP
40 BLK/WHT 351
GND SENSOR
53 BLK 407 BLK M GRY B A
LO REF
57 ORG 440
B+
58 DK GRN 1049
CLS 2 DATA
59 YEL 710 YEL/BLK L BRN
CLS 2 DATA
63 BLK 452 PNK E RED
SENS GND S116
72 YEL 772
PRND B
74 YEL 410 3-2 SHIFT
ECT SIG
75 PNK 1020 SOLENOID
IGN
79 WHT 687 WHT S WHT B A RED
3-2 SS
80 BLK 2761
SENS GND
C1 (RIGHT REAR
OF CYLINDER TCC PWM
1 BLK/WHT 351 BLK/WHT HEAD) SOLENOID
GND G103
2 BRN 418 S106 BRN U TAN B A RED
TCC PWM
6 RED/BLK 1228
PC SOL HI
8 LT BLU/WHT 1229 PRESS CTRL
PC SOL LO
16 GRY/BLK 1694 4WD CIRCUIT SOLENOID
4WD LOW
19 BLK/WHT 1695 (W/ 2 SPEED RED/BLK C PPL A B
FRT AXLE SW TRANSFER CASE)
20 LT GRN/BLK 822
VSS LO
21 PPL/WHT 821 LT BLU/WHT D LT BLU
VSS HI
24 DK BLU 417 TCC
TP SIG
40 BLK/WHT 351 SOLENOID
GND
42 TAN/BLK 422 TAN/BLK T BLK B A RED
TCC SOL
46 BRN/WHT 419
MIL CTRL
47 YEL/BLK 1223 YEL/BLK B YEL B A RED
2-3 SS
48 LT GRN 1222
1-2 SS
51 YEL/BLK 1227
TFT SENS SIG 2-3 SHIFT
62 GRY 773 SOLENOID
PRND C
63 PNK 1224 LT GRN A LT GRNB A RED
TRANS RNG A
C2
POWERTRAIN CONTROL 1-2 SHIFT
MODULE SOLENOID
(RIGHT FRONT OF
BARE

ENGINE COMPT) AUTOMATIC

TRANSMISSION
(4L60-E)
VSS
S140
ADAPTER
(4WD)
(LEFT
BLK

SIDE OF
B LT GRN/BLK

TRANS)
S152
A PPL/WHT

C DK BLU

A BLK/WHT

D BLK/WHT

BLK/WHT

G104
A BLK

B BLK
A GRY
B YEL

(LEFT REAR
OF CYLINDER
C WHT
B GRY

D YEL

HEAD)
C2

C1

C B P A G105
(LEFT REAR
ENGINE THROTTLE OF CYLINDER
COOLANT HEAD)
POSITION
VEHICLE TEMPERATURE SENSOR
SPEED SENSOR SENSOR (ON THROTTLE
(RIGHT REAR PARK/NEUTRAL
(ON LEFT BODY POSITION SWITCH
OF TRANS) CYLINDER ASSEMBLY) (LEFT SIDE OF
HEAD, BETWEEN TRANSMISSION)
REAR PLUGS)
152485
4.3L VIN W, A/T Wiring Diagram, 4L60-E

HOT IN HOT AT HOT AT HOT IN HOT IN PARK

C BRN RUN ALL TIMES ALL TIMES START OR NEUTRAL
I/P FUSE UNDERHOOD
BLOCK 4WD CTSY LP ATC CRANK BTSI FUSE BLOCK
B PPL/WHT (ON LEFT FUSE 15 FUSE 8 FUSE FUSE FUSE (ON TOP OF
END OF 10A 10A 20A 10A 10A LEFT FRONT
C2 INTERIOR DASH) FENDER)
ILLUMINATION LIGHTS
LAMP SYSTEM E5 D5 C3 C1 C12 C2
H GRY

LT GRN/BLK
PPL

PPL
BRN

ORG

ORG

ORG
SOLID 4WD LO
STATE INDICATOR S208
C PPL/WHT

BRN
H
SPLICE PACK STARTING/
SP200 CHARGING
4WD HI

ORG

ORG
(CENTER OF SYSTEM
INDICATOR
D TAN/BLK DASH)
G 2 DOOR 4 DOOR

BRN
2WD HI
INDICATOR INTERIOR

LT GRN/
BLK

LT GRN/
BLK
E LT GRN/BLK LIGHTS
A
FRONT SYSTEM
LT GRN/
A GRY/BLK AXLE WHT E
INDICATOR
4WD HI SWITCH K
SWITCH (ON FRONT E
B SPLICE STOPLIGHT
AXLE, RIGHT PACK
B DK GRN/WHT SWITCH

BLK/WHT
OF DIFF) SP204
2WD HI STOPLIGHT (CENTER
SWITCH SWITCH M OF DASH)

LT GRN/
BLK

LT GRN/
BLK
F DK GRN/WHT
S121
4WD LO (BODY HARN,
BLK/WHT

BLK/WHT
SWITCH 6.5 CM FROM
BLOWER
G BLK 2 DOOR 4 DOOR
MOTOR
C1 BREAKOUT)
(RIGHT FRONT OF

LT GRN/
BLK
TRANSFER CASE SHIFT ENGINE COMPT)
CONTROL SWITCH ANTI-LOCK
BRAKES POWERTRAIN
SYSTEM CONTROL MODULE
1695 BLK/WHT 19
AXLE SW
C1 GRY/BLK 1694 1694 GRY/BLK 16
4WD LO SELECTED 4WD LO IN
C2 817 DK GRN/WHT 50
VS SIGNAL
C3 DK GRN/WHT 1559 C2
4 LO REQUEST
C4 DK GRN/WHT 1562
2 HI REQUEST
C5 GRY/BLK 1564 ORG
4 HI REQUEST A4
C6 ORG 40 ORG
12V BATTERY
C7
INTERIOR
C8 BRN 241 LIGHTS
12V IGNITION (3)
C9 BLK/WHT 1554 SYSTEM
ENCODER SIG GROUND
C10 BLK 1050
GROUND BODY RELAY
C11 LT GRN/BLK 1563
2 HI STATUS LAMP BLOCK
C12 TAN/BLK 1566 (BEHIND LEFT
4 HI STATUS LAMP
C13 SIDE OF DASH)
C14 PPL/WHT 1565
4 LO STATUS LAMP
C15
C16 BLK 1552
MOTOR CONTROL A

DATA LINK 13 ORG

CONNECTOR (DLC)
(PARTIAL)
(UNDER LEFT
SIDE OF DASH)
D1 RED 1553
MOTOR CONTROL B
D2 LT GRN/BLK 584
(A/T) PNP SWITCH IN
D3 ORG 1568
DATA LINK CONNECTOR
D4 BRN/WHT 1555
ENCODER CHANNEL-P CRUISE
D5 RED/WHT 1556 CONTROL DK GRN/WHT
ENCODER CHANNEL-C D
D6 DK BLU/WHT 1557 SYSTEM DK GRN/WHT
ENCODER CHANNEL-A
D7 YEL/BLK 1558
ENCODER CHANNEL-B
D8 DK GRN/WHT 817 DK GRN/WHT F
VEHICLE SPEED IN
D9 INSTRUMENT DK GRN/WHT
D10 CLUSTER SPLICE PACK
& SOUND SP200
D11 SYSTEMS (CENTER
D12 BLK 1050 OF DASH)
GROUND
D13 BLK 1050
GROUND
D14 ORG 1640
BATTERY
D15 ORG 1640
BATTERY
D16 PPL 806
IGNITION

TRANSFER CASE SHIFT

CONTROL MODULE
(BEHIND RIGHT FRONT
KICK PANEL)
BLK
2 DK BLU/WHT

C
BLK
4 BRN/WHT
8 RED/WHT

3 BLK/WHT
1 YEL/BLK

BLK
B
BLK
6 RED

7 BLK

SPLICE PACK
SP204
(CENTER TRANSFER
ENCODER CHANNEL B

ENCODER CHANNEL A

ENCODER CHANNEL C

ENCODER CHANNEL P

ENCODER GROUND

OF DASH) CASE
ENCODER
M BLK M MOTOR
J BLK
SHIFT
MOTOR

SPLICE PACK
SP203
BLK

BLK

(NEAR
ASHTRAY)
G203 G205
(RIGHT SIDE (RIGHT SIDE
OF DASH) OF DASH)
152499

4.3L VIN W, Transfer Case Wiring Diagram, with 2-Speed Selectable Transfer Case
4.3L VIN X

HOT IN RUN HOT AT HOT IN HOT IN OFF, HOT IN RUN

OR START ALL TIMES RUN RUN, OR START OR START
UNDERHOOD I/P FUSE (UNDER DASH,
FUSE BLOCK ABS CLSTR GAUGES BLOCK ON HEATER
ECM I ECM B
(ON TOP OF FUSE 22 FUSE 11 FUSE 4 (ON LEFT CASE)
FUSE FUSE
LEFT FRONT 10A 10A 10A END OF BODY CONTROL
15A 20A
FENDER) DASH) MODULE
PNK B2
A10 A8 B8 C2 LT GRN A12
BRN PNK PNK PNK
C1
PNK ORG ORG UTILITY W/
FLOOR SHIFT A7
INSTRUMENT YEL A1
S203 S113 PANEL C2
CLUSTER
BRN BRN PNK PNK PNK SOLID (IPC)
D STATE LT GRN M
STOPLAMP DK GRN B
ELECTRONIC SWITCH A/T INSTRUMENT MIL PPL A
BRAKE (ON BRAKE SHIFT CLUSTER (SERVICE
CONTROL PEDAL LOCK ENGINE
MODULE SUPPORT SOLENOID SOON IND) SPLICE PACK
C BRACKET) SP201
(BEHIND
A11 LEFT SIDE
PPL OF DASH)
S138 BRN/
(BODY HARN, NEAR WHT PPL 2 DATA LINK
PPL PPL BREAKOUT TO CONNECTOR
BLOWER MOTOR (UNDER
RESISTOR) LEFT SIDE
OF DASH)
CRUISE
CONTROL &
ANTI-LOCK A/T FLUID
BRAKES PRESSURE
1 BLK/WHT 351
GND SYSTEMS MANUAL VALVE
8 GRY 416 POSITION SWITCH
+5V
17 DK BLU 1225 DK BLU R DK BLU E
RANGE B D3, D2
18 RED 1226 RED P ORG D
RANGE C D4, D2
19 PNK 439 PNK N PNK C
IGN REV, LO
20 ORG 440
B+
32 BLK/WHT 771
PRND A
33 PPL 420
BRK SW
34 WHT 776
PRND P FLUID TEMP
40 BLK/WHT 351
GND SENSOR
53 BLK 407 BLK M GRY B A
LO REF
57 ORG 440
B+
58 DK GRN 1049
CLS 2 DATA
59 YEL 710 YEL/BLK L BRN
CLS 2 DATA
63 BLK 452 PNK E RED
SENS GND S116
72 YEL 772
PRND B
74 YEL 410 3-2 SHIFT
ECT SIG
75 PNK 1020 SOLENOID
IGN
79 WHT 687 WHT S WHT B A RED
3-2 SS
80 BLK 2761
SENS GND
C1 (RIGHT REAR
OF CYLINDER TCC PWM
1 BLK/WHT 351 BLK/WHT HEAD) SOLENOID
GND G103
2 BRN 418 S106 BRN U TAN B A RED
TCC PWM
6 RED/BLK 1228
PC SOL HI
8 LT BLU/WHT 1229 PRESS CTRL
PC SOL LO
16 GRY/BLK 1694 4WD CIRCUIT SOLENOID
4WD LOW
19 BLK/WHT 1695 (W/ 2 SPEED RED/BLK C PPL A B
FRT AXLE SW TRANSFER CASE)
20 LT GRN/BLK 822
VSS LO
21 PPL/WHT 821 LT BLU/WHT D LT BLU
VSS HI
24 DK BLU 417 TCC
TP SIG
40 BLK/WHT 351 SOLENOID
GND
42 TAN/BLK 422 TAN/BLK T BLK B A RED
TCC SOL
46 BRN/WHT 419
MIL CTRL
47 YEL/BLK 1223 YEL/BLK B YEL B A RED
2-3 SS
48 LT GRN 1222
1-2 SS
51 YEL/BLK 1227
TFT SENS SIG 2-3 SHIFT
62 GRY 773 SOLENOID
PRND C
63 PNK 1224 LT GRN A LT GRNB A RED
TRANS RNG A
C2
POWERTRAIN CONTROL 1-2 SHIFT
MODULE SOLENOID
(RIGHT FRONT OF
BARE

ENGINE COMPT) AUTOMATIC

TRANSMISSION
(4L60-E)
VSS
S140
ADAPTER
(4WD)
(LEFT
BLK

SIDE OF
B LT GRN/BLK

TRANS)
S152
A PPL/WHT

C DK BLU

A BLK/WHT

D BLK/WHT

BLK/WHT

G104
A BLK

B BLK
A GRY
B YEL

(LEFT REAR
OF CYLINDER
C WHT
B GRY

D YEL

HEAD)
C2

C1

C B P A G105
(LEFT REAR
ENGINE THROTTLE OF CYLINDER
COOLANT HEAD)
POSITION
VEHICLE TEMPERATURE SENSOR
SPEED SENSOR SENSOR (ON THROTTLE
(RIGHT REAR PARK/NEUTRAL
(ON LEFT BODY POSITION SWITCH
OF TRANS) CYLINDER ASSEMBLY) (LEFT SIDE OF
HEAD, BETWEEN TRANSMISSION)
REAR PLUGS)
152485

4.3L VIN X, A/T Wiring Diagram, 4L60-E

 HOT IN HOT AT HOT IN HOT IN RUN
START ALL TIMES RUN OR START
UNDERHOOD I/P FUSE
CRANK ATC FUSE BLOCK 4WD GAUGES BLOCK
FUSE FUSE (ON TOP OF FUSE 15 FUSE 4 (ON LEFT END
10A 20A LEFT FRONT 10A 10A OF DASH)
FENDER)
PNK
BODY
C3 C1 D5 E5 C1

BRN
CONTROL
MODULE INSTRUMENT

PNK
2 PPL

PPL

PPL
DATA LINK

ORG

ORG

BRN
PANEL CLUSTER
CONNECTOR (DLC)
(PARTIAL) H
SPLICE SERVICE

BRN
(UNDER LEFT 4WD IND
SIDE OF DASH) STARTING/ PACK
CHARGING SP200
SYSTEM (CENTER OF
SPLICE A PPL G J
DASH) PNK A7
PACK SOLID
SP201 G GRY GRY A6 STATE
(BEHIND C DK GRN/WHT

BRN

BRN
LEFT SIDE B DK GRN
OF DASH) (LEFT REAR
OF ENGINE
BARE S134 BLK COMPT)
A A G117
FRONT FRONT BARE
58 DK GRN AXLE AXLE
CLASS II DATA INDICATOR VACUUM FRONT
C1 SWITCH SOLENOID YEL A
PROPSHAFT
(ON FRONT (ON FIREWALL, SPEED
B AXLE, RIGHT B NEAR SENSOR
16 GRY/BLK
4WD LO OF DIFF) WINDSHIELD
C2 WIPER PPL B

BLK/WHT

GRY/BLK
POWERTRAIN MOTOR)
CONTROL MODULE
(RIGHT FRONT OF REAR
LT BLU A
ENGINE COMPT) PROPSHAFT
SPEED
SENSOR
E1 TAN 1569 DK GRN B
LOCK SOL OUT
E2
E3 PNK 1561
4WD IND
E4 LT GRN/BLK 1563
2-HI IND
E5 BRN/WHT 1555
CHANNEL-P
E6 RED/WHT 1556
CHANNEL-C
E7 YEL/BLK 1558 BRN C
CHANNEL-B
E8 DK BLU/WHT 1557 INTERIOR PPL/WHT B
CHANNEL-A
E9 DK GRN/WHT 1133 LIGHTS C2
CLASS II SERIAL DATA SYSTEM
E10 BRN 241
IGNITION
E11 PPL 806 PNK F
IGNITION
E12 YEL 400
FT SHAFT SPEED HI 4WD IND
E13 PPL 401
FT SHAFT SPEED LO
E14 BLK/WHT 1695 LT GRN/BLK E
AXLE SW SIG
E15
E16 BLK/WHT 451 2-HI IND
MODULE GROUND
F1 PPL/WHT 1565 PPL/WHT C SOLID
4-LO IND
F2 TAN/BLK 1566 STATE
4-HI IND 4-LO IND
F3 BRN 1560
NEUTRAL IND
F4 GRY/BLK 1570 TAN/BLK D
CLUTCH SOL SIG
F5 LT BLU 2221 C1
RR SHAFT SPEED LO 4-HI IND
F6 DK GRN 2222
RR SHAFT SPEED HI
F7 GRY/BLK 1694 BRN D
4WD LO IND SIG
F8 C2
F9 NEUTRAL IND
F10
F11
F12 BLK/WHT 1554 4H
ENCODER SIG RTN
F13 LT GRN/BLK 431
+8V REF OUT
F14 LT GRN/BLK 431 LT GRN/BLK A 2H
+8V REF OUT
F15
F16 LT BLU 1693
4WD SW SIG 4L
C1
BLK/WHT

D ORG 1640 FWD

B+
C BLK 1050
GROUND
B RED 1553 B7 LT BLU B
MOTOR FEED B
A BLK 1552 BODY GRY H
MOTOR FEED A
C2 RELAY
BLOCK
TRANSFER CASE SHIFT (BEHIND INTERIOR
CONTROL MODULE B5 LEFT SIDE LIGHTS ILLUM
(BEHIND RIGHT OF DASH) SYSTEM LAMPS
BLK/WHT

FRONT KICK PANEL)

BLK

BLK G
C1
ORG

DK BLU/WHT
RED

TAN
BLK

LT GRN/BLK

C E8 C1 TRANSFER CASE SHIFT

BRN/WHT
RED/WHT
BLK/WHT

CONTROL SWITCH
YEL/BLK

SPLICE UNDERHOOD
C1

PACK FUSE
D
A

SP204 BLOCK
BLK

(CENTER
B OF E7 C2
NCA

NCA

NCA

NCA

C2

DASH)
D
E

BLK/WHT
F

BLK

M
SPLICE
PWR

GND

PACK
SP203
(NEAR
J ASHTRAY)
M +8V S152
BLK/WHT

REF
BLK
BLK

ENCODER MOTOR
MOTOR LOCK
DECODER LOGIC G205 G105 G203
(RIGHT SIDE (LEFT REAR OF (RIGHT SIDE
OF DASH) CYLINDER HEAD) OF DASH)
152497 TRANSFER CASE ENCODER MOTOR

4.3L VIN X, Transfer Case Wiring Diagram, with 2-Speed Automatic Transfer Case
 HOT IN HOT AT HOT AT HOT IN HOT IN PARK
C BRN RUN ALL TIMES ALL TIMES START OR NEUTRAL
I/P FUSE UNDERHOOD
BLOCK 4WD CTSY LP ATC CRANK BTSI FUSE BLOCK
B PPL/WHT (ON LEFT FUSE 15 FUSE 8 FUSE FUSE FUSE (ON TOP OF
END OF 10A 10A 20A 10A 10A LEFT FRONT
C2 INTERIOR DASH) FENDER)
ILLUMINATION LIGHTS
LAMP SYSTEM E5 D5 C3 C1 C12 C2
H GRY

LT GRN/BLK
PPL

PPL
BRN

ORG

ORG

ORG
SOLID 4WD LO
STATE INDICATOR S208
C PPL/WHT

BRN
H
SPLICE PACK STARTING/
SP200 CHARGING
4WD HI

ORG

ORG
(CENTER OF SYSTEM
INDICATOR
D TAN/BLK DASH)
G 2 DOOR 4 DOOR

BRN
2WD HI
INDICATOR INTERIOR

LT GRN/
BLK

LT GRN/
BLK
E LT GRN/BLK LIGHTS
A
FRONT SYSTEM
LT GRN/
A GRY/BLK AXLE WHT E
INDICATOR
4WD HI SWITCH K
SWITCH (ON FRONT E
B SPLICE STOPLIGHT
AXLE, RIGHT PACK
B DK GRN/WHT SWITCH

BLK/WHT
OF DIFF) SP204
2WD HI STOPLIGHT (CENTER
SWITCH SWITCH M OF DASH)

LT GRN/
BLK

LT GRN/
BLK
F DK GRN/WHT
S121
4WD LO (BODY HARN,

BLK/WHT

BLK/WHT
SWITCH 6.5 CM FROM
BLOWER
G BLK 2 DOOR 4 DOOR
MOTOR
C1 BREAKOUT)
(RIGHT FRONT OF

LT GRN/
BLK
TRANSFER CASE SHIFT ENGINE COMPT)
CONTROL SWITCH ANTI-LOCK
BRAKES POWERTRAIN
SYSTEM CONTROL MODULE
1695 BLK/WHT 19
AXLE SW
C1 GRY/BLK 1694 1694 GRY/BLK 16
4WD LO SELECTED 4WD LO IN
C2 817 DK GRN/WHT 50
VS SIGNAL
C3 DK GRN/WHT 1559 C2
4 LO REQUEST
C4 DK GRN/WHT 1562
2 HI REQUEST
C5 GRY/BLK 1564 ORG
4 HI REQUEST A4
C6 ORG 40 ORG
12V BATTERY
C7
INTERIOR
C8 BRN 241 LIGHTS
12V IGNITION (3)
C9 BLK/WHT 1554 SYSTEM
ENCODER SIG GROUND
C10 BLK 1050
GROUND BODY RELAY
C11 LT GRN/BLK 1563
2 HI STATUS LAMP BLOCK
C12 TAN/BLK 1566 (BEHIND LEFT
4 HI STATUS LAMP
C13 SIDE OF DASH)
C14 PPL/WHT 1565
4 LO STATUS LAMP
C15
C16 BLK 1552
MOTOR CONTROL A

DATA LINK 13 ORG

CONNECTOR (DLC)
(PARTIAL)
(UNDER LEFT
SIDE OF DASH)
D1 RED 1553
MOTOR CONTROL B
D2 LT GRN/BLK 584
(A/T) PNP SWITCH IN
D3 ORG 1568
DATA LINK CONNECTOR
D4 BRN/WHT 1555
ENCODER CHANNEL-P CRUISE
D5 RED/WHT 1556 CONTROL DK GRN/WHT
ENCODER CHANNEL-C D
D6 DK BLU/WHT 1557 SYSTEM DK GRN/WHT
ENCODER CHANNEL-A
D7 YEL/BLK 1558
ENCODER CHANNEL-B
D8 DK GRN/WHT 817 DK GRN/WHT F
VEHICLE SPEED IN
D9 INSTRUMENT DK GRN/WHT
D10 CLUSTER SPLICE PACK
& SOUND SP200
D11 SYSTEMS (CENTER
D12 BLK 1050 OF DASH)
GROUND
D13 BLK 1050
GROUND
D14 ORG 1640
BATTERY
D15 ORG 1640
BATTERY
D16 PPL 806
IGNITION

TRANSFER CASE SHIFT

CONTROL MODULE
(BEHIND RIGHT FRONT
KICK PANEL)
BLK
2 DK BLU/WHT

C
BLK
4 BRN/WHT
8 RED/WHT

3 BLK/WHT
1 YEL/BLK

BLK
B
BLK
6 RED

7 BLK

SPLICE PACK
SP204
(CENTER TRANSFER
ENCODER CHANNEL B

ENCODER CHANNEL A

ENCODER CHANNEL C

ENCODER CHANNEL P

ENCODER GROUND

OF DASH) CASE
ENCODER
M BLK M MOTOR
J BLK
SHIFT
MOTOR

SPLICE PACK
SP203
BLK

BLK

(NEAR
ASHTRAY)
G203 G205
(RIGHT SIDE (RIGHT SIDE
OF DASH) OF DASH)
152499

4.3L VIN X, Transfer Case Wiring Diagram, with 2-Speed Selectable Transfer Case