Temperature Measurement
Temperature Measurement
BASIC PRINCIPLES
Mrs. Tannistha Kapoor Engr. O&M/C&I
Agenda
1. INTRODUCTION 2. THERMOELECTRIC THERMOMETRY 3. RESISTANCE THERMOMETRY
INTRODUCTION
TEMPERATURE:It is a physical property of the system It is the degree of hotness or coldness It is the result of the motion of the particles that make up the system It is measured in degrees in the scales:- Farenheit( oF) , Celsius( oC) & kelvin.
5/23/2012 11:50:36 PM
THERMOELECTRIC THERMOMETRY
PRINCIPLES
When a closed loop is formed between two metals joined at two places with temperature difference between the junctions, an emf is generated.
(SB & SA are Seebeck coefficients measured in V/K) When a current I is made to flow through the circuit, heat is evolved at the upper junction (at T2), and absorbed at the lower junction (at T1). The Peltier heat absorbed by the lower junction per unit time, is equal to (Where AB is the Peltier coefficient of the entire thermocouple, and A and B are the coefficients of each material) THERMOCOUPLE RESISTOR PYROMETER
THOMSON
SEEBECK
PELTIER
Any current-carrying conductor with a temperature difference between two points, will either absorb or emit heat, depending on the material.
Metals such as zinc and copper exhibit positive Thomson effect while metals such as cobalt, nickel, and iron exhibit negative Thomson
effect.
4
5/23/2012 11:50:36 PM
5/23/2012 11:50:36 PM
COLD JUNCTION
THERMOSTAT
HEATER
Isothermal Block
A B
HJ
EXTENSION WIRES
Amplifier
M U X
A / D
HJ
Electrical compensation
MEAS. DEV
B
EXTENSION WIRES
P/S
THERMALLY INSULATED BLOCK
RTD 5/23/2012 11:50:36 PM
NEGATIVE LEG
CONSTANTAN
BS COLOR CODE
COMMENTS
T J E K
GOOD GENERAL PURPOSE, LOW TEMPERATURE, TOLERANT TO MOISTURE. HIGH TEMPERATURE, REDUCING ENVIRONMENT
IRON
CONSTANTAN
0 O +700
-180 TO +800
CHROMEL
CONSTANTAN
0 TO +800
-40 TO +900
GENERAL PURPOSE, LOW AND MEDIUM TEMPERATURES GENERAL PURPOSE HIGH TEMPERATURE, OXIDIZING ENVIRONMENT
CHROMEL
ALUMEL
0 TO +1100
-180 TO +1300
R
S N B
PLATINUM
0 TO +1600
PLATINUM
0 TO +1600
-50 TO +1750
NISIL
0 TO +1100
-270 TO +1300
+200 TO +1700
0 TO +1820
5/23/2012 11:50:36 PM
Extension cable
Compensating cable
>Installation Practices :-Observe colour codes & polarity of connection for each type of thermocouple. - Avoid subjecting different metals into cabling. Use minimum no. of connections in the measuring circuit. -Where thermocouple RJC is used, the thermocouple should run continuously to the reference unit without break. In case of larger distances extension cables are to be used. -RJC units should be located away from hostile environment or inaccessible locations. - Avoid subjecting compensating cables to high temperatures to avoid inaccuracies.
5/23/2012 11:50:36 PM 8
5/23/2012 11:50:36 PM
10
5/23/2012 11:50:36 PM
11
5/23/2012 11:50:36 PM
12
> Headless Thermocouples :THERMOCOUPLES WITH COMPENSATING CABLE THERMOCOUPLES WITH BAYONET FITTING
5/23/2012 11:50:36 PM
13
5/23/2012 11:50:36 PM
5/23/2012 11:50:36 PM
15
5/23/2012 11:50:36 PM
16
FAILURE MODES: OPEN CIRCUIT :- RESULTS IN LOWER READING. SHORT CIRCUIT :- RESULTS IN LOWER READING.
5/23/2012 11:50:36 PM
17
5/23/2012 11:50:36 PM
18
5/23/2012 11:50:36 PM
19
RESISTANCE THERMOMETRY
RTD RESISTANCE TEMPERATURE DETECTORS.
>These temperature sensors utilises the predictable change in resistance of
certain materials with temperature changes. >The relation between temperature and resistance is given by CallenderDussen equation
Van
(where RT is the resistance at T C and Ro is the temperature at 0 C.A,B,C are constants.) > Temperature characteristic of an RTD is specified by a single no. alpha, representing the average temperature coefficient over 0 -100 degC temperature range as calculated byalpha = ( R100 - R0 ) / 100 . R0 in ohms/ohm/C beta = 0 for temp > 0degC and 0.11 for temp <0 deg C delta = 1.5 (approx)
,
5/23/2012 11:50:36 PM
,
20
RTDs are available in a variety of forms. They are > Wire wound :- It is built by simply winding a small diameter platinum sensing wire around a mandrel constructed of non-electrically conductive material The sensing wire is attached to the larger lead usually by resistance spotwelding and/or hightemperature soldering. The sensing wire is then overcoated with a nonconductive protective coating such as ceramic cement, or glassy coating.
5/23/2012 11:50:36 PM
21
5/23/2012 11:50:36 PM
22
5/23/2012 11:50:36 PM
23
> Sheath materials :Commonly used sheath materials for industrial sensors and their recommended service are as follows: - Brass. Used for low-temperature commodity applications in mild environments such as air or water temperature measurements. - 304 stainless steel. Good corrosion-resistant characteristics and adequate for most common corrosive agents encountered in industry; service temperatures up to 900F; advantages for machined housings. -316 stainless steel. The most corrosion resistant of the common stainless steels; increased corrosion resistance to non-oxidizing acids such as sulphuric, phosphoric, and acetic; service temperature up to 900F;. - Inconel 600. Better high-temperature corrosion resistance than stainless steels; pre-oxidized sheaths for temperatures up to 1500F;
5/23/2012 11:50:36 PM 24
TEMPERATURE RANGE
ALPHA
COMMENTS
COPPER
Pt
-200C to 260C
0.00427
Low cost
MOLYBDENUM
Mo
-200C to 200C
0.00300 0.00385
NICKEL
Ni
-80C to 260C
0.00672
NICKEL - IRON
Ni-Fe
-200C to 200C
0.00518
Low cost
PLATINUM
Pt
-240C to 660C
5/23/2012 11:50:36 PM
25
RTD DISADVANTAGES :>Much more expensive than thermocouples as metal used must be in purest form. >Cannot measure a wide temperature range. >Power supply failure can result in erroneous readings. >Since changes in resistance are measured all connections must be tight and corrosion free.
5/23/2012 11:50:36 PM
26
5/23/2012 11:50:36 PM
27
5/23/2012 11:50:36 PM
28
5/23/2012 11:50:36 PM
-Usually employees mercury and operates on the principle of liquid expansion. e.g. Mercury in steel thermometers. - Advantages are evenly divided calibrated scales, vide variation of range, no errors introduced due to change in atmospheric pressure, ample power for operating bourdon tube. - Main disadvantage is that where process medium must not be contaminated by Hg, a small leak may prove hazardous. Vapour pressure filled system :- These are partially filled with a volatile liquid and operate on the principle of vapour pressure. -Particularly useful where long distances are required between bulb and reading instrument, or where temperature is to be measured over a wide range with greater accuracy in the upper part of scale. -Since inert liquid is used any kind of leaks do not prove hazardous. -Main disadvantage is unequally divided scale. Gas filled system :- Operates on the principle of change of pressure of a constant volume of gas contained in a bulb, caused by temperature variations. - Advantages are evenly divided scale and capability of measuring lower temperatures upto 160deg C against -70decC & -30deg C for vapour and liquid filled sys. Respectively)
5/23/2012 11:50:36 PM 30
ROD TYPE
CAPILLARY TYPE
5/23/2012 11:50:36 PM
31
The elements may be in the form of straight strip, circle, helix or mainspring. The deflection of helix is much more than the other two. Used when it is required to operate an alarm or control circuit. Main advantages are simple construction, faster response than filled system, can operate a switch directly. Main disadvantages are it must be directly immersed in the measured medium. In case of vibrations helix type is unstable.
5/23/2012 11:50:36 PM
33
SIGNAL PROCESSING
For power plant applications the mv signal from thermocouples or resistance signals from RTDs require some sort of processing before they can be used for indication, recording or control purposes. Signal processing may be done either in the DCS system or on location itself. For on location signal processing special transducers which convert primary signal to 4-20mA DC signal are used. In DCS system the raw signals from primary transducers are converted to digital signals using special input modules depending on the type of primary sensing element. These digital signals may then be used for further processing or may be converted to 4-20mA DC signals through special output modules for use in indicators and recorders. For all thermocouples with reference junction compensation, the system must be offset by the reference junction temperature.
5/23/2012 11:50:36 PM
35
5/23/2012 11:50:36 PM
36
TEMPERATURE CALIBRATION
All Sensors change their characteristics with time. Hence timely calibration of sensors is required for accurate temperature measurement. Temperature calibration may be done at three levels-Primary laboratories, Secondary laboratories ,Industrial calibration. Variety of heat sources are available for calibration, the most popular being dry block calibrators. However liquid baths and multipurpose sources are becoming increasingly popular. DRY BLOCK CALIBRATORS:Dry blocks have a metal block into which the temperature sensors to be calibrated are placed. The block is heated or cooled to the desired temperature. Dry blocks fall into three temperature ranges, dictated by material availability, heater and cooling technology.
-Peltier driven equipment: Peltier modules are solid state heat pumps. Dry blocks utilising this type of device have advantages of being able to heat and cool, are often portable and typically have fast heating and cooling rates. Peltier driven equipment has a typical operating range of -40 to 140C.
5/23/2012 11:50:36 PM 37
PORTABLE LIQUID BATHS :Portable stirred liquid baths have a well which is filled with a liquid. The liquid is stirred and heated or cooled to the desired temperature. They are ideal for awkward shaped and short sensors. Accuracies are in general better than dry blocks due to the lack of air gaps and the temperature uniformity of the stirred liquid. Water filled baths are to be used for temperature 0 to 100deg C.Oil baths are to be used for temperatures only above 100 degC
5/23/2012 11:50:36 PM
38
5/23/2012 11:50:36 PM
40
Temperature Measurement
5/23/2012 11:50:36 PM
41