A Seminar-Report: Topic Air Brake System of Indian Railways
A Seminar-Report: Topic Air Brake System of Indian Railways
A Seminar-Report: Topic Air Brake System of Indian Railways
SUBMITTED BY:
SUBMITTED TO:
DEPARTMENT OF MECHANICAL ENGG. HARYANA ENGINEERING COLLEGE (JAGADHRI)
BRAKING SYSTEM
INTRODUCTION:-The most vital factor in the running and control of any
vehicle whether it is a cycle, scooter, car, bus, or train is the breaking system. In order slow down the moving vehicle in a shorter possible time, the energy of motion possessed by vehicle must be converted in to other forms. During break application in any vehicle the energy of motion is converted in to heat. This u might have noticed at the rim when you apply brakes repeatedly at short intervals.
Basic requirements of brake:Keeping in the view the safety of human life and physical resources the basic requirements of brake are: 1. brake must be strong enough to stop the vehicle during an emergency with in a shorter possible distance. 2. there should be no skidding during brake application &driver must have proper control over the vehicle during the emergency. 3. effectivness of brakes should remain constant even on prolonged application or during descending on a down gradient. 4. brake must keep the vehicle in a stationary position even when the driver is not present.
of brakes because single train pipe. successive brake application on gradients are not effective as piston
takes longer time for release. # vacuum brakes are not suitable for high speed trains the maximum
pressure available for brake application is only atmospheric. Thebrake power is inadequate for higher loads and speed. # period. brake power destroyed over the period of time as train run over long
AIR BRAKE
1. Brake application is takes place when pressure is dropped in brake pipe 2. during brake application the piston is pushed outward.
* Various stages of brake application are - Minimum application - Service application - Full service application - Emergency application
* As compared to single pipe graduated release air brake system twin pipe graduated release air brake system is more suitable for passenger coaches
The twin pipe graduated release air brake system consists of following components:1. Distributor valve 2. Common pipe bracket with control reservoir 3. Auxiliary reservoir(200lts) 4. Three way centrifugal dirt collector 5.Isolating cock 6. Check valve with choke 7. Brake cylinder (355 mm diameter)
8. Cut of angle cock(25 mm feed pipe )size on either ends of brake pipe as well as 9. Air brake hose coupling (32 mm for brake pipe ) 10. Air brake whose coupling (32 mm for feed pipe) 11. Passenger emergency alarm valve 12. Passenger emergency signal device with resetting key 13. Brake pipe and feed pipe (25mm dia.) 14. Branch pipes from BP and FP to brake equipment (20 mm bore) 15. Branch pipe connecting passenger emergency alarm valve and passenger emergency alarm signal device(10 mm bore) 16. Guard emergency brake valve 17. Pressure gauges for BP and FP
Principal of operation: -
(2)
Brake pipe throughout the length of the train is charged with compressed air at 5kg/sq.cm. Feed pipe throughout the length of the train is charged with compressed air at 6 kg/sq. cm. Control reservoir is charged to 5kg/sq.cm. Auxiliary reservoir is charged to 6kg/sq.cm.
(3)
For brake applicant the brake pipe pressure is dropped by venting air from the drivers brake value subsequently the following a chain takes place. The control reservoir is disconnected from the brake pipe. The distributor value connects the auxiliary reservoir to the brake cylinders and the brake cylinders piston is pushed outwards for applicant of brakes. The auxiliary reservoir is however continuously charged from feed pipe at 6Kg 1cm2.
Brake release Stage: Brake are released by recharging pipe 5Kg2 pressure through the drivers brake value The distributor value isolated the brake cylinders from the auxiliary reservoir.
The brake cylinder through pressure is vented to atmosphere through DV and the brake cylinders piston moves in words.
Parameters
Emergency braking distance (4500 t level track, 65 kmph)
Air Brakes
Vacuum Brakes
632m
1097m
No fading
At least by 20%
275kg
700kg
Pressure Gradient
No appreciable difference Steep reduction in in air pressure between vacuum in trains longer locomotive and brake van than 600m. up to 2000m.
Preparation time in departure yards (45 BOX or 58 BOXN) Safety on down gradients
Up to 4 hours.
Very safe
Overall reliability
Very good
Satisfactory