Chapter 3
Chapter 3
8.
3.2 SOURCES
3.2.1 NATURAL SOURCES
Rain, snow, hail and sleet are precipitated upon the surface of the earth as meteorological water and may be considered as the original source of all the water supplied. Water, as source of drinking water, occurs as surface water and ground water. Three aspects should be considered in appraising water resources e.g., the quantity, the quality, and the reliability of available water.
18
channels, and then into natural or artificial storage sites (or into the ocean in coastal areas). The amount of available surface water depends largely upon rainfall. When rainfall is limited, the supply of surface water will vary considerably between wet and dry years. Surface water supplies may be further divided into river, lake, and reservoir supplies. Dams are constructed to create artificial storage. Canals or open channels can be constructed to convey surface water to the project sites. The water is also conveyed through pipes by gravity or pumping. In general, the surface sources are characterized by soft water, turbidity, suspended solids, some colour and microbial contamination.
Ground water that flows naturally from the ground is called a Spring.
19
1.
Waste water, agricultural runoff, grazing of livestock, drainage from mining areas, runoff from urban areas, domestic and industrial discharges may all lead to deterioration in physical, chemical, or biological/bacteriological water quality within a reservoir. Farming practices Fish die off. Natural factors: Climate: temperature, intensity and direction of wind movements as well as the type, pattern, intensity and duration of precipitation, Watershed and drainage areas: geology, topography, type and extent of vegetation, and use by native animals; Wild fires; Reservoir Areas: geology, land form including depth, area and bottom topography and plant growth at the time the reservoir is filled.
2. 3. 4.
3.3.3.2 Thermal Stratification Thermal stratification develops in lakes and reservoirs when the surface water begins to warm. The warm surface waters expand and become lighter than the lower waters. The water temperature difference causes variation in water densities, which create resistance to mixing. This ultimately results in Anaerobic Conditions in lower zones. 3.3.3.3 Anaerobic Conditions Anaerobic conditions make water unpalatable due to colour and odour which are difficult to treat. Another major problem in anaerobic water occurs when iron and/or manganese exist in bottom sediments in the reduced state and pass into solution. Due to the presence of either iron or manganese in appreciable quantities within the domestic supply the water looks reddish, brown or just plain dirty and may stain clothes during washing and stain porcelain fixtures.
20
Following are some of the probable essential factors, which should be investigated in a sanitary survey.
ii) iii)
21
Wind direction and velocity data; drift of pollution; algal growth potential in case of lake or reservoir supplies. Character and quality of raw water. Protective measures in connection with the use of watershed to control fishing, boating, swimming, wading, ice cutting, and permitting animals on shoreline areas. Efficiency and constancy of policing activities on the watershed and around the lake.
22
3.6.1.3 Dams-Operational Functions 1. General The releases through the Outlet-works shall be made according to the predetermined regulations to suit the availability and demand. 2. Spillway The water in excess of demand can be stored up to a predetermined level. Surplus water shall be automatically released through the pre-designed spillway. 3. Outlet works During normal operation, the supplies shall be released through the outlet pipe. The downstream valve shall be used for regulation purposes and the upstream valve for emergency operation. 4. Gauging facilities Gauges should be installed at suitable locations in approach channel, stilling basin and escape channel etc. and read at predetermined times. 5. Initial filling of reservoir After completion of all works the impounding shall be carried out in stages. During initial filling a gradual rise in reservoir level is desired to avoid chances of a possible mishap due to leakage. 6. Water level measurements Water level in the reservoir shall be recorded once a day during non-monsoon period and thrice a day during monsoon period or as decided by the Authorities keeping in view the local conditions. 7. Storage Utilisation The initial live storage goes on reducing due to silting with passage of time. This point should be kept in mind while utilising the stored water. 8. Outlet operation While the outlet starts operating, careful watch shall be kept to see if there is any formation of vortices or swirl around the intake structure. Precautions shall be taken to regulate the flow through outlet by operating control valves. 9. General Precautions Before the beginning of the monsoon season every year, it shall be ensured that all electrical and mechanical equipments are in perfect working order. Spillway and outlet structures shall be free of any unauthorised installation or devices. General vigilance shall be maintained on inflow conditions. Flood warnings shall be issued to all concerned. Strict watch shall be kept on the magnitude of inflow and outflow discharge.
10. Flood Control Changing characteristics of the inflow, reservoir sedimentation and variations in water
23
use shall demand reassessment of flood retaining capacity and requirements. River downstream of dam must be periodically inspected for alterations in water use or obstruction and/or possible danger of damage from flooding to life and property. 11. Emergency precautions and operations Emergency action plans shall deal with the following aspects Hydrological observations and flood warning schemes; Drawdown and flood control operation of reservoir; Emergency emptying of the reservoir; Evacuation of the flood threatened areas; Rescue operations and other emergency provisions; Equipment, material and support available for emergency relief; Emergency stand by of the public utilities; Emergency warning; Emergency communication and transportation; Emergency access to remote sites.
3.6.1.4 Inspection of Dams For proper Operation and Maintenance of a dam and adopting remedial measures, regular inspection of the dam, appurtenant structures, reservoir area, and downstream channel in the vicinity of the dam should be conducted in a systematic manner. Adequacy and quality of maintenance and operating procedures and operation of control facilities should be properly examined and all possible remedial measures should be taken to set right the deficiencies so detected. Particular attention should be given to detecting evidences of leakage, erosion, seepage, excessive wetness or slushiness in the area downstream of dam, presence of sand boils, change in water table conditions downstream, slope instability, undue settlement, displacement, tilting, cracking, deterioration and improper functioning of the drains and relief wells, evidence of excessive pore pressure conditions, encroachment on the free board allowance. Following guidelines outline some of the factors to be duly considered to ensure implementation of the operation and maintenance procedures. (a) Embankment Structures 1. Settlement The embankments and downstream toe areas should be examined for any evidence of localized or overall settlement, depressions or sinkholes. 2. Slope Stability Embankment slopes should be examined for irregularities in alignment and variances from smooth uniform slopes, unusual changes from original crest alignment and elevation, evidence of movement at or beyond the toe, and surface cracks which indicate movement.
24
3.
Seepage The downstream face of abutments, embankment slopes and toes, embankmentstructure contacts, and the downstream valley areas should be examined for evidence of existing or past seepage. The presence of animal burrows and tree growth on slopes which may cause detrimental seepage should be examined.
4.
Drainage Systems The slope protection should be examined to determine whether the systems could freely pass discharge and that the discharge water is not carrying embankment material.
5.
Slope Protection The adequacy of slope protection against wave, currents and surface runoff that may occur at the site should be evaluated. The condition of vegetation cover should be evaluated.
(b) Spillway Structures Examination should be made of the structures and important features of all service and auxiliary spillways, which serve as principal or emergency spillways. 1. 2. 3. 4. (c) Control gates and operating machinery. Unlined saddle spillways. Approach and Outlet channels. Stilling basin (Energy dissipators).
Outlet Works The outlet works examination should include all structures and features designed to release reservoir water below the spillway crest through or around the Dam. 1. Intake Structure: Entrances to intake structure should be examined for conditions such as silt or debris accumulation, which may reduce the discharge capabilities of the outlet works. 2. 3. 4. 5. 6. Operation and emergency control gates. Conduits, sluices, water passages etc. Stilling Basin (Energy dissipaters). Approach and outlet channels. Drawdown facilities.
Facilities provided for drawdown of the reservoir to avert impending failure of the dam or to facilitate repair in the event of stability or foundation problems should be examined. (d) Concrete Structure in General The examination of concrete structures shall include the following: 1. 2. 3. Concrete surfaces. Structural cracking. Movement - horizontal and vertical alignment.
25
4 . Junctions. 5 . Drains-Foundation, Joint, Face. 6 . Water Passages. 7 . Seepage or leakages. 8 . Monolith joints-construction joints. 9 . Foundations. 10. Abutments. (e) Reservoir
The following features of the reservoir should be examined to determine to what extent the water impounded by the dam would constitute a danger to the safety of the dam or a hazard to human life or property. 1. Shore Line The landforms around the reservoir should be examined for indications of major landslide areas which may reduce reservoir capacity or create waves that might overtop the dam. 2. Sedimentation The reservoir and drainage area should be examined for excessive sedimentation or recent developments in the drainage basin, which could cause a sudden increase in sediment load thereby reducing the reservoir capacity. 3. Backwater flooding The reservoir area should be examined for features subject to potential backwater flooding resulting in loss of human life and property. 4. Watershed Runoff Potential The drainage basin should be examined for extensive alterations to the surface of the drainage basin such as changed agricultural practices, timber clearing, railroad or highway construction or real estate developments that might extensively affect the runoff characteristics. Upstream projects that might have impact on the safety of the dam should be identified. (f) Downstream Channel
The channel immediately downstream of the dam should be examined for conditions, which might impose any constraints on the operation of the dam. (g) Special Observations 1. 2. Every attempt should be made to anticipate and have engineer-observers present on site at items of large spillway and outlet discharge. Warning, safety and performance instrumentations: piezometers, flow recorders, accelerometers, seismoscopes, joint meters, and gauge points, strain meters, stress meters, inclinometers, direct and inverted plumblines, surface reference monument, stage recorders, extensiometers,
26
3.
serviceability, access to readout stations, need for recalibration, faulty readings and reasons, alarm systems.
During and after floods: drift marked high water-lines, evidence of taxed spillway capacity, undesirable or dangerous spillway flow patterns,
4.
During and after large outlet releases: Undesirable or dangerous spillway flow patterns, dynamic pressures, vibrations cavitation sonics.
5.
After earthquakes: cracks, displacement offsets in structural features, cracks, slumps, slides, displacements, settlements in embankments, cut-slopes, and fill slopes, broken stalactites in galleries, tunnels, chambers, toppled mechanical equipment, sand boils.
6.
Surface evaporation Direct evaporation from water surface is influenced by temperature, barometric pressure, mean wind velocity, vapour pressure of saturated vapour and vapour pressure of saturated air. Measurement of evaporation from water surfaces are commonly made by exposing pans of water to the air and recording the evaporation losses. The evaporation from lakes, dams, impounding reservoirs, various structures in which water surface is exposed to the atmosphere, may result in considerable loss of water. Evaporation is a direct function of the surface area. An attempt should be made to minimize the surface area. Evaporation is a continuous process. It cannot be eliminated though it can be controlled by use of certain chemicals developed specially for this purpose. Such chemicals are generally available in paste form and can be brought into the liquid form by mixing water. This can then be spread over the surface of water so as to form a thin film. This film is normally retained on the surface for more than 24 hours and needs to be replenished by spreading the chemical again. The film is transparent and sun rays can pass through it and the aquatic life is thus protected. The film is likely to be disturbed by wind which affects its covering efficiency. The cost of this process is quite high. Calculations should be made on the cost of this treatment versus the extra cost in arranging additional water. In certain circumstances, when alternative sources are not available, this process will be very useful.
27
3.6.1.5 Earthen Dams Following features should be examined for proper operation and maintenance. (a) Stress and Strain: Evidence and clues 1. 2. 3. 4. 5. 6. 7. 8. 9. Settlement, Consolidation, Subsidence, Compressibility, Cracks, displacement, offsets, joint opening changes in concrete facing on rock fills, Loss of freeboard from settlement, Zones of extension and compression visible along dam crest or elsewhere, Crushing of rock points of contact, Differential settlement of embankment cross sectional zones visible along dam crest.
(b) Stability : Evidence and clues 1. 2. 3. 4. (c) Cracks, displacements etc., on embankment crest and slopes. Sags and misalignments in parapet wall etc., Irregularities in alignment and variances from smooth, uniform face planes, Bulges in ground surfaces beyond toes of slopes.
Inadequate seepage control: Evidence and clues 1. 2. 3. 4. 5. 6. 7. Wet spots, New vegetal growth, Seepage and leakage, Boils, Saturation patterns on slopes, hillsides and in streambed, Depressions and sinkholes, Evidence of high escape gradients.
(d) Erosion Control 1. 2. Loss, displacement, and deterioration of upstream face riprap, underlayment and downstream face slope protection, Leaching.
(e) Foundation 1. 2. 3. 4. Piping of weathering products, Efficiency of foundation seepage control systems, History of shear zones, faults, openings, Zones of varying permeability,
28
5. 6.
Effect on permeability, uplift, foundation stability, Subsurface erosion and piping etc.
3.6.1.6 O&M of Concrete Dams (these observations are applicable also to impounding reservoirs, intake structures, spillway control structures, lock walls). Examine for evidence and clues for (a) Stress and Strain: Evidence and Clues: 1. Cracks, crushing, displacements, offsets in concrete monoliths, buttresses, face slabs, arch barrels visible on exterior surfaces and in galleries, valve and operating chambers, and conduit interior surfaces, Typical stress and temperature crack patterns in buttresses, pilasters, diaphragms and arch barrels,
2.
(b) Stability: 1. 2. 3. 4. 5. (c) Uplift pressures, pressure spurts from foundation drain holes, construction joints, and cracks, Differential displacements of adjacent monoliths, buttresses and supported arch barrels or face slabs, Disparities in regions near the interface between arches and thrust blocks, Movement along construction joints, Uplift on horizontal surfaces.
Hillslides and river channels along the downstream toe of the dam: 1. 2. 3. 4. Leakage, Seepage, Stability, Boils.
(d) Stability and seepage control at discontinuities and junctures: 1. 2. 3. (f) Embankment wrap around sections, Water stops in monoliths and face slabs, Reservoir impounding backfill at spillway control sections and retaining walls.
Foundations: 1. 2. 3. 4. 5. 6. Piping of weathering products, Foundation seepage control systems, History of shear zones, faults, cavernous openings, Zones of varying permeability, Effect on permeability, uplift, foundation stability, Subsurface erosion and piping.
29
3.6.1.7 Miscellaneous Items Observe following features: (a) Service reliability of outlet, spillway sump pump mechanical-electrical equipment i) ii) iii) iv) v) vi) Broken or disconnected lift chains and cables, Test operation including auxiliary power sources, Reliability and service connections of primary sources, Verification of operators understanding and ability to operate, Ease and assurance of access to control stations, Functioning of lubrication systems.
(b) Gate chamber, Galleries, Tunnels and Conduits Ventilation and heat control of damp, corrosive environment of mechanical-electrical equipment. (c) Accessibility and Visibility i) ii) iii) iv) i) ii) iii) iv) Vegetable overgrowth, Galleries-access ladders, lighting, Access roads and bridges, Communication and remote control lines, cables and telemetering systems. Harmful vegetation in embankments-oversize, dead root channels, Harmful vegetation in structural concrete joints, Obstructing vegetal growth in hydraulic flow channels, Ground squirrels, rats and beavers.
3.6.1.8 Records of operation of Reservoir In order to ensure continued safe operation of dam and appurtenant works, including mechanical and electrical equipment installed therein, a record of operation and inspection of various works/equipment shall be maintained on suitable history sheets for future reference and guidance. Details of maintenance of all works undertaken and modifications, if any, carried out shall be carefully recorded so that proper assessment can be made subsequently in respect of adequacy/efficacy of repairs and modifications carried out. History sheets shall be prepared subsequently for civil, mechanical and electrical works. The record thus maintained shall be carefully scrutinized from time to time and remedial measures, as considered necessary, be taken. The records shall include all items mentioned in item 3.6.1.4. (Operation and Maintenance).
3.7 INTAKES
3.7.1 GENERAL
An Intake is a device or structure placed in a surface water source to permit withdrawal of water from this source and its discharge into an intake conduit through which it will flow
30
into the water works system. Types of intake structures consist of intake towers, submerged intakes, intake pipes or conduits, movable intakes, and shore intakes. Intake structures over the inlet ends of intake conduits are necessary to protect against wave action, floods, stoppage, navigation, ice, pollution, and other interference with the proper functioning of the intake. Intake towers are used for large waterworks drawing water from lakes, reservoirs and rivers in which there is either or both a wide fluctuation in water level or the desire to draw water at a depth that will give water of the best quality to avoid clogging or for other reasons.
31
Lack of use, Lack of lubrication, Vibration, Improper operating procedures, Design errors or deficiencies, Failure of power source or circuit failure, and Vandalism.
3.7.5 SAFETY
When working around Intake Structures proper safety procedure involving use of electrical and mechanical equipment and water safety should be observed. Proper safety procedures should be documented and included in the manual containing the operating procedure. For more details please refer to the Chapter 19 on Safety Practices.
A significant change in any of the first seven conditions listed above indicates that a well or pumping rate is in need of attention.
32
Preventive maintenance programme begins with well construction records showing geological condition, water quality and pumping performance. The data of optimum and efficient limit of operation should be available which is created at the time of testing and commissioning of the well. This data is normally in the form of a discharge draw-down curve (called yield draw down curve). According to this curve there is a straight line up to certain stage of draw down beyond, which the draw down increases disproportionately to yield. The end point of straight line is the point of optimum efficiency for the operation of well as shown in the attached figure.
This is generally found to be 70% of yield at draw down which can be created 3.8.1.1 Static Water Level (S.W.L.) Pumping water level and Draw Down can be measured with the help of an electrical depth gauge of an Air line gauge. In case of measurement by an electrical depth gauge an electrode is suspended in the tube well by a metallic cloth tape. The conductor terminal clip is fixed with the metallic casing of the tube well. The electric circuit is completed when the electrode touches the water surface which is indicated by the galvanometer. The corresponding depth is read on the tape. Air line gauge method is most commonly used for measurement of S.W.L., Pumping Water Level and draw down. Air pipe can be lowered in tube well through a slot or a hole provided in the flange in case of flanged assembly and in the annular space in case of socketed assembly. In this method air is pumped into the line until the maximum possible pressure is reached. Normally the air line is full of water up to the level of water in the well (static or pumping water level). When air is forced into the line, it creates pressure which forces water out of the lower end until it is completely expelled and the line is full of air. If more air is pumped in, air, instead of water, is expelled and it is not possible to increase the pressure further. The head of water, C or E (as shown in the figure), above the end of the line maintains this pressure,
33
and the gauge shows the pressure or head above the end of the line. If the gauge is graduated in meters of water, it registers directly the amount of submergence of the end of the line. This reading subtracted from the length A of the line, gives the water level B or D (static or pumping water level). 3.8.1.2 Tubewell sounding For identification of lithological details electrical logging can be used for uncased bores while Gamma logging can be used for both, cased and uncased bores. Bore hole camera can be used for identification of the condition of bore hole, casing and strainer pipes. These devices are commonly available in the market.
34
Ground Water Sources are costly structures which require careful design, construction, operation and timely maintenance. A trouble free service can be ensured by adopting the aforesaid practices. However, it has been experienced that a large number of Ground Water Sources constructed at high costs, operate at very low efficiencies or fail completely. The indication of source failures is either excessive sand pumping or steady decline in well yield. It may often be possible in few cases to rehabilitate the source by carrying out suitable remedial measures, but in most of the cases even the costly operations may not be effective to restore the source. In such cases the source is abandoned and a new source will have to be constructed.
Causes of failure of well mentioned above from (i) to (viii) are applicable according to type of source. The table at Annexure-3.1 indicates all causes of failure according to type of source.
35
and maintenance may result in poor performance of the tube well. Therefore, before any permanent damage is done to tube well it should be ensured that the tube well is operated at its designed capacity and timely repair and maintenance are done. 3.8.4.2 Adverse Aquifer Conditions In adverse aquifer conditions where water table has depleted but the quality has not deteriorated, wells can generally be pumped with considerable reduced discharge. 3.8.4.3 Mechanical Failure The falling of pumping set assembly and its components into the bore hole can be minimised by providing steel wire holdings throughout around the assembly length including pumping set or by providing and clamping a steel strip around the pumping assembly. However, in spite of proper care sometimes foreign objects and pumping set assembly components may fall in the well. In corrosive water the column pipe joints and pump parts may get progressively weakened due to corrosion, get disconnected and fall into the well. These foreign & falling objects may damage the well screen resulting into failure of the well. However where well screen is not damaged, then by proper fishing the fallen objects can be taken out of the well making it functional again. Following are the steps taken for fishing out the fallen objects in the bore holes: (a) Impression Block An impression block is used to obtain an impression of the top of the object before attempting any fishing operation. Impression blocks are of many forms and design. Figure 3.1 illustrates an impression block made from a block of soft wood turned on a lathe. The diameter of the block is 2 cm less than that of drilled hole. The upper portion is shaped in the form of a pin and driven to fit tightly into the box collar of a drill pipe. To ensure further safety, the wooden block is tied with wire or pinned securely to the collar. Alternatively, the block could be fixed to a bailer. A number of nails are driven to the lower end of the block with about 1 cm of it projecting out. A sheet metal cylinder of about 5 to 7 cm is temporarily nailed around the block to hold molten wax, which is poured into it. Warm paraffin wax, soap or other plastic material poured into the cylinder is left to cool and solidify. The metal cylinder is then removed. The nail heads hold the plastic material to the block. To locate the position of a lost object, the impression block is carefully lowered into the hole until the object is reached. After a proper stamp is ensured, the tool is raised to the ground surface, where the impression made in the plastic material is examined for identifying the position of the lost object and designing or selecting the right fishing tool. (b) Fishing Tools to Recover Fallen Objects The term fish, as used in tube well technology, describes a well drilling tool, pump component or other foreign body accidentally fallen or struck in bored wells & wells. The type of fishing tools required for a specific job will depend on the object to be lifted and the position in which it is lying in the well. It may often be necessary to design a fishing tool to suit a particular job. However, series of fishing tools suitable for different jobs are available in the market, which could be adapted or modified to suit a particular requirement.
36
3.8.5 INCRUSTATION
3.8.5.1 Diagnosing Incrustation Problem Chemical incrustation is indicated by a gradual reduction in yield of the well. However, it can also happen with a gradual lowering of the water table due to over-pumping or inadequate ground water recharge. This fact can be verified by studying the behaviour of the ground water level over the service period of the tube well. Incrustation in the form of slime produced by iron bacteria decreases well yield due to clogging of the well screen and casing. Incrustation also clogs the fractures & fissures of rocky zone of well which is prevalent in bore wells. This trouble can be identified from the performance curves of the well. In this case the reduction in well yield is somewhat more rapid. Water quality analyses are used to identify the type of incrustation.
37
3.8.5.2 Types of Incrustation The various types of incrustation in order of the frequency of occurrence are: Precipitation of carbonates, sulphates and silicates of calcium and magnesium. Precipitation of hydroxides, oxides and other compounds of iron and manganese. Slime produced by iron bacteria and other slime producing organisms. Deposition of soil materials (Mechanical Incrustation).
(a) Calcium and Magnesium Calcium carbonate is one of the most extensively found minerals. Its solubility depends upon the quantity of free carbon dioxide in the water which in turn depends upon the pH, the temperature and the pressure. On pumping, a low pressure zone is created around the well and some of the dissolved carbon dioxide is released from solution. Some calcium bicarbonate is then reconverted into calcium carbonate which is deposited as a cement like material on the screen and in the sand and gravel around it. This incrustation builds up a shell around the screen which may be several centimeters thick. Partial incrustation may extend back as much as a metre into the water-bearing formation. In addition to the sand grains around the well which are cemented together, other substances like aluminium silicates, iron compounds and organic material may also be entrapped in the carbonate scales. Many a time the calcium carbonate may only be a small fraction of the deposit but is usually the basic binder. This type of deposit accounts for about 90 per cent of the cases of incrustation. (b) Iron and Manganese Salts Bicarbonates of iron and manganese are more soluble in water than their hydroxides. In incrusting regions the ground water is generally charged to its full capacity with these salts. It is believed that an increase of its velocity in the vicinity of the well is enough to upset the balance and precipitate out the insoluble iron and manganese hydroxides. These are jelly like and fluffy. Oxidation can then occur due to the dissolved oxygen in the water and these are transformed into hydrated oxides. Hydrated ferrous oxide is a black sludge while ferric oxide is reddish brown like common crust. Ferrous bicarbonates are moderately soluble in water, the solubility increasing if the water is acidic. Ferric salts are, however, insoluble in alkaline or weakly acidic water. Thus a reduction of acidity can also cause precipitation of the iron salts. Ferrous bicarbonates also get oxidised when they come in contact with oxygen to form insoluble ferric hydroxide. 4Fe(HCO3)2 + O2 + 2 H2 O = 4Fe(OH)3 + 8 CO2 Oxidation is more marked in water table tubewells, which are run intermittently, because air can get into the zone of daily depletion of water table and oxidise the salts there. In such cases sand particles of the aquifer can get progressively coated with iron oxide, thus reducing the void spaces and encroaching upon the storage capacity of the formation. Clogging by manganese occurs much less frequently. Soluble manganese bicarbonates react with oxygen to form insoluble manganese hydroxide which precipitates as a sooty or dark brown deposit. In general, waters containing more than 400 ppm bicarbonates, 100 ppm sulphates, or 400 ppm silicates can be considered incrusting. Water containing 2 ppm iron or 1 ppm manganese can be considered incrusting. Water can also pick up iron from the well casing itself.
38
(c) Bacteria Iron bacteria such as crenothrix grow attached to the screen or voids of the aquifer, and feed on carbon compounds like bicarbonates and carbon dioxide in addition to the iron in solution. Release of carbon dioxide, deficiency of oxygen, and darkness favour their growth. During their life cycle they change the dissolved iron into the insoluble ferric state. This is deposited in the void of the aquifer surrounding the screen or in a jelly like sheath which surrounds the bacteria. This slime can clog the screen slots and the pores of the aquifer. They may grow in water pipes as well and clog the same. Similar bacteria can also cause oxidation manganese compounds to insoluble form. Sometimes sulphate reducing bacteria are also found in ground water which reduce the sulphates in the water to hydrogen sulphide. Hydrogen sulphide so formed attacks the iron pipes to form insoluble iron sulphide, which deposits as a scale. (d) Silt and Clay Deposits (Mechanical Incrustation) Silt and clay material can sometimes move on to the screen and clog the same. This may also clog the fractures & fissures of rocky zone of a well which is prevalent in bore wells. Such clogging may be because of improper development or inadequate design and construction.
39
acid cannot be obtained, a home-made inhibitor can be used. A solution of about 0.7 kgs of gelatine in warm water, added to 100 litres of acid is usually adequate. (b) Treatment procedure 1. The arrangement of equipment required for hydrochloric acid treatment is shown in Fig. 3.2. It consists of a 2 to 2.5 cm diameter plastic pipe which is long enough to reach the bottom of the well. The pipe, supported by suitable clamps, is lowered into the well. The upper end of the pipe is provided with a funnel inlet and overflow arrangement with a T-joint. The overflow takes care of any sudden blow out. A solution of hydrochloric acid is prepared as indicated above. The acid solution required for one treatment should be 1.5 to 2 times the volume of water in the screened portion of the well. Sufficient acid is poured into the well to fill the bottom 1.5m depth of the screen. The acid-feeding pipe is then raised to about 1.5m and more acid poured. Even though acid is heavier than water and will displace it, the two will mix readily when stirred and the acid becomes easily diluted.
2.
40
3.
The effectiveness of acid treatment depends upon the contact between the chemical and the deposits on the well screen as well as in the adjacent aquifer. Chemical penetration will follow the path of least resistance. Hence, it is difficult to treat a clogged aquifer. It is, therefore, essential to agitate the acid solution vigorously and to surge it with a view to forcing the solution into the aquifer formations offering resistance. As soon as the acid solution is poured, it should be agitated in the well for one to two hours, with the help of a surge plunger. The solution should then be bailed out. Bailing is continued until almost clear water is obtained. In the second stage of treatment, the process is repeated using the same quantity of acid. Surging is continued for a longer period before bailing out the water. Generally, two treatments should be sufficient to achieve the desired results. During acid treatment, neighbouring wells within a 60m radius should not be operated.
4.
(c)
Adaptability
Hydrochloric acid treatment is best suited when incrustation is due to calcium and magnesium carbonates. The treatment may not be successful in removing iron and manganese crusts. It attacks the steel well casing to some extent. However, damage can be minimised by using suitable inhibitors. Hydrochloric acid treatment is not suitable for agricultural strainers which consist of brass wire-mesh wrapped over a perforated galvanized iron pipe. In such a screen, treatment will result in rapid electrolytic corrosion of the screen. (d) Safety measures Hydrochloric acid is harmful to skin and can result in serious injury to eyes, if handled carelessly. Similarly, formation of gases, when the acid is poured into the well, can cause suffocation which could be fatal. Therefore, necessary care should be taken while treating the well. Good ventilation should be provided in the area around the pump house. All persons handling the acid should use rubber gloves and protective masks. A box of baking soda is kept handy, to neutralise the effect of acid if it falls on the body. 3.8.6.2 Sulphamic Acid Treatment 1. Hydrochloric acid and sulphamic acid are used when calcium carbonate is the principal incrusting material. Although it is more expensive than hydrochloric acid but it has number. of advantages i.e. it is less aggressive, it is relatively safe to handle and it does not attack M.S. well casings like hydrochloric acid. Hence, sulphamic acid is commonly used for treatment in case of wells having mild steel screens or casings with deposits of calcium and magnesium salts. Sulphamic acid (NH2SO3H), is commercially available in granular and pelletised forms. It is available under different trade names having a corrosion inhibitor and a wetting agent. A colour indicator is also introduced in the pellet which would change the colour of the solution from violet to orange yellow, once the incrustation is completely dissolved. Sulphamic acid is soluble in water and the weak solution does not give any hazardours fumes nor irritates the skin. Sulphamic acid in granular form is poured into the well through a plastic or iron pipe. The material so poured is agitated to dissolve it in water. Sometimes it is poured into the well in a 20 per cent solution with water. In this case, first the solution is prepared
2.
41
by dissolving one bag of acid (powder or pellets) at a time in a 200 litre capacity drum. Arrangement is made for pouring the solution to the bottom end of the tube well. This is done by a 25 mm or suitable diameter PVC siphon tube, keeping one end of it in a funnel at the top of another 25 mm pipe already lowered into the bottom of the tube well through the space between the pump and well casing. The end of the siphon is to be kept in the tank containing the sulphamic acid solution. The solution is then poured into the tube well through the pipe. The rate of feeding of the solution is controlled by a valve provided at the end of the delivery pipe so that the solution enters the tube well gradually in order to avoid faster chemical reaction at the initial stage. The feeding rate is regulated in such a way that the entire solution is added over a period of 2 to 3 hours. The solution is allowed to remain in the tube well for about 24 hours. 3. When the acid is available in pelletised form, the pellets could be dropped directly into the well in small quantities. Additional granular material is added to the well, as the reaction proceeds so as to keep the required strength of the solution. With surging, the reaction can be completed in 16 to 24 hours. After this period of 16-24 hours, about 4 to 6 hours of adding the chemical, the well is developed by compressed air or pump. This will loosen the incrusted chemical on the tube well screen and the surrounding aquifer. The tube well water is then pumped out. Pumping is continued intermittently for about 10 hours, till clean water is obtained. The quantity of the sulphamic acid required depends on the quantity of water in the well. The usually recommended quantity of sulphamic acid (by weight) to be added in a tube well is about 7 to 10 per cent of the weight of water in the well. Thus, in a 20 cm diameter tubewell with a water column of 100m, the volume of water being 3.14 m3, the total quantity of sulphamic acid required for a treatment is about 250kg. It is often desirable to add a corrosion inhibitor and a wetting agent (low detergent soap) to improve the performance of the acid. The quantities of both these additives are about 10 per cent each of the weight of sulphamic acid. The corrosion inhibitor prevents corrosive action of the acid on the metal of the well pipe. The wetting agent improves the dispersing and cleaning action of the acid. Fluronic F-68 or Pluronic L62 are commonly used as wetting agents. When the two additives are used with the acid, it is necessary to mix them in a bucket containing clean water, so as to form a heavy but pourable slurry, and add this slurry to the well through a tube. The solubility of sulphamic acid decreases with decrease in temperature as shown in Table No.1
TABLE 1: SOLUBILITY OF SULPHAMIC ACID IN WATER
Temperature C Dry acid solubility in 100 litres of water, kg Acid concentration of saturated solution, % 5 17 14 10 18 15 15 20 17 25 23 19
4.
5.
42
6. Safety precautions Sulphamic acid in granular and pelletised forms, though less aggressive than hydrochloric acid, should be handled with caution. However, when used as a concentrated solution, it should be very carefully handled. Water-proof gloves and goggles should be worn by those handling it. Hydrogen sulphide and carbon dioxide gases are produced in considerable volumes during the reaction. The former is produced when iron sulphate is present. Both these gases are heavier than air. Hence, no person should be allowed to stand in a depression or a pit near the well during treatment. 7. Necessary conditions for acid treatment The following are the major requirements for acid treatment of water wells: i) ii) iii) The metal of the well screen must be such that it is not damaged by the acid. The well screen must be constructed of a single metal in order to avoid electrolytic corrosion, as in the case of a bi-metallic alloy. A fair knowledge of the kind of incrusting material is essential to determine the proper procedure in well treatment. Samples of incrustations taken from other wells in the same formation are useful indicators of the causes of incrustation. Water quality analysis is also useful to obtain information on the kind of incrusting material. Adequate ventilation of well treatment site is necessary. Wells located in the neighbourhood (within 30m) of the well must be shut down during the process of treatment.
iv) v)
In all acid treatments, the acid should be handled with care. Good ventilation should be provided when operating in a confined area, like a pump house. Adequate provision should be made for disposing the waste water which is pumped out during its treatment. The waste water must be kept away from domestic wells, ponds or other water bodies used for human or cattle consumption. The waste, when diluted, will not adversely affect plants. Pumping the waste during acid treatment is a process of brisk surging, followed by slow pumping until the water becomes clear and free of odour and foam. 3.8.6.3 Aquifer Conditions which may not Respond to Acid Treatment Acid treatment of water wells, though suitable under most conditions, may not result in any appreciable improvement under the following aquifer conditions: i) ii) iii) Shallow limited aquifers, subjected to recurring periods of over-draft. Deeply buried narrow aquifers approaching over-development. Aquifers of low permeability where operating heads are large.
Controlled pumping tests to determine well efficiencies and the hydraulic characteristics of aquifers are essential in determining the effectiveness of acid treatment or other development methods to increase the yield of water wells.
43
3.8.6.4 Glassy Phosphate Treatment Glassy phosphate or polyphosphates are used for well treatment when iron oxide, manganese oxide, silt and clay are the materials causing incrustation. Sodium hexameta phosphate (NaPO3)6 is one of the most commonly used polyphosphates. They do not dissolve the incrusting material and fuming or boiling does not take place. Phosphates have cleaning and dispersing properties which, when coupled with vigorous agitation, break the incrusting material. Thus, the incrustation gets dispersed and is easily pumped out. Calcium hypochlorite is also added to it in small quantities. It helps in chlorinating the well and killing the iron bacteria or similar organisms which may be present in well water. (a) Treatment procedure: Glassy phosphate solution is prepared in a tank or drum. The amount of glassy phosphate to be added depends on the quantity of water in the well. Generally, 15 to 30kg of glassy phosphate is used for every 1000 litres of water in the well. It should be dissolved in water by suspending it in a tank in a cloth net or gunny bag, and should not be simply dumped. A mixture of about 1.2 kg of calcium hypochlorite per 1000 liters of water is desirable. It helps kill iron bacteria and other organisms. The solution so prepared is poured into the well. This is followed by vigorous surging, which will help the chemical loosen and disperse the deposits inside the pipe as well as outside. The dispersed material passes out through the screen openings. Surging can be done using a surge plunger, compressed air, or by horizontal jetting. If the pump installed in the well is not removed, the same can be used for surging. Surging by pumping is not very effective but can be used for convenience. Surging with a pump is done by starting and stopping it as often as possible. Operation is continued for a period of about four hours. The pump is then left idle for about two hours. The process is repeated twice or thrice. When the chemical has been in the well for about 24 hours, surging is again repeated several times. The waste is then pumped out and the well flushed thoroughly. Even while the well is being flushed out, surging is done a few times at intervals, and pumping continued until fairly clean water is obtained. The entire procedure may be repeated two or three times, using a fresh charge of polyphosphates and calcium hypochloride. The chemical is quite safe to use and does not require any special safety precautions. (b) Removal of Hydrogen Sulphide (H2S) Bio Fouling: Sulphate reducing bacteria in ground water reduce the sulphates in the water to hydrogen sulphide, which produces foul smell known as bio fouling. This bio fouling can be removed by the method mentioned above. This can also be removed by super chlorination of water. Aeration method as mentioned at para 7.2 of Manual of Water Supply and Treatment (1999 Edition) can also be used for removal of the H2S bio fouling. 3.8.6.5 Chlorine Treatment In case of wells incrusted with bacterial growth and slime deposits, chlorine treatment has been found most effective. Though acid may kill the bacteria, it is unable to remove the slime. Chlorine kills the bacteria as well as oxidises the organic slime, thus loosening it. Calcium hypochlorite Ca(OCI)2 is often used for chlorine treatment. It is available in powder form, containing about 70 per cent free chlorine. The quantity required is generally 20 to 25kg
44
for deep wells. Sodium hypochlorite Na OCI can also be used. Sometimes chlorine gas in water solution is also used but special equipment is required for its application.
Treatment procedure
The desired amount of the chemical is put in the well directly, or in a water solution, to give the proper concentration of chlorine. When chlorine solution is used, it can be introduced into the well slowly through a plastic pipe of small diameter, over a period of about 12 hours in case of large wells. About 14 to 18 kgs of chlorine will be required for this purpose. Small wells require less chlorine and the period of application can be decreased accordingly. Chlorine is corrosive in the presence of water. It should, therefore, be handled carefully so that it does not harm the pump, well casing and screen. It is not necessary to remove the pump, but it should be ensured that the plastic pipe carrying concentrated chlorine solution is not discharging the liquid directly on any part of the pump, well casing or screen. As soon as the chlorine solution is introduced, a sufficient quantity of water (50 to 100 times the volume of water standing in the well) is added to the well from an outside source, with a view to forcing the chlorine solution into the water-bearing formation. The well is then surged, using any of the standard techniques of surging. In case the pump has not been removed, the same can be used for surging, though not very effectively. Successful chlorine treatment of a well may require three or four successive operations. 3.8.6.6 Combined Hydrochloric Acid and Chlorine Treatment Hydrochloric acid treatment followed by chlorine treatment is highly effective. The acid readily dissolves the carbonates while the chlorine helps to remove the slime deposited by iron bacteria. The two treatments are alternated, the acid treatment being performed first. The cycle may be repeated two or more times. 3.8.6.7 Dry Ice Treatment The use of dry ice to open up incrusted screens is still in the experimental stage. Dry ice is carbon dioxide gas which is solidified by application of a large pressure. When it is put into a well, it is quickly converted into gas is not allowed to escape and is forced through the screen. In this process the material choking the screen is loosened. There may also be some reconversion of salts into soluble bicarbonates due to the action of dry ice. Dry ice can also be used after acid treatment for agitating and creating back pressures for surging. It may cause severe burns if it comes in contact with the body. Hence heavy gloves or tongs should be used while handling it. 3.8.6.8 Hydro Fracturing This process is, generally, not used in this country for development purposes. Hydro fracturing is a process used to open-up clogged fractures and fissures in the rock surrounding the bore well by injecting water at a very high pressure. Hydro fracturing method can be used for rejuvenation of a low yielding or nearly dry bore well at a cost of 10 to 70% of the cost of bore well. (a) Conditions necessary for hydro fracturing 1. Low yield/dry bore wells shall be considered for hydro fracturing.
45
2. 3. 4. 5. 6.
Lithology of each bore well should be known. Well-logging to be conducted to confirm the lithology and fracture zones of the bore well. Quality of the water to be known. Bore well should be of sufficient depth. Bore well should be in good condition (like uniform diameter and verticality).
(b) Basic components of hydro fracturing unit The basic components of the hydro fracturing unit include packer assembly, hydraulic pump for packing, supercharge pump for injecting water under high pressure, water tank, generator and submersible pumps of different horse powers. The packer assembly is supported by hydraulic hose and steel rope. (c) Operation Single Packer Double Packer Hydro fracturing can be carried out by
In the single packer technique, the packer will be placed above the fracture/work zone in the bore well and the bottom of the bore well acts as the closed end. In the double packer system, the packers are placed at the predetermined depths within the bore well. The verticality of the bore well is checked up to the depth of packer setting and the packer is lowered and fixed by applying hydraulic pressure up to 300-350 bars and followed by injection of water into the bore well under great pressure, depending upon the depth, dimension and area of fracture. The pressure ranges from few tens to 170 bars. Once the maximum pressure builds up, the fractures, fissures, joints will break and interconnects among them and the pressure drops down suddenly indicating the development of fresh fractures or interconnection of existing fractures. Thus, this process can be repeated for lower fracture zones also. Subsequently, well logging and pump test will be conducted to assess the degree of hydro fracturing and improvement in yield. Figure 3.3 indicates a set up of hydro fracturing unit. 3.8.6.9 Explosives These are sometimes employed to develop and enlarge incrusted crevices and fissures of bore wells. Charges are used according to the hardness of the rock and the depth at which the charge is to be detonated.
46
1.
Redevelopment of well involves removal of finer material from around the well screen, thereby enlarging the passages in the water-bearing formation to facilitate entry of water. Redevelopment removes clogging of the water-bearing formation. It increases the porosity and permeability of the water-bearing formation in the vicinity of the well. It stabilize the formations around the well screen so that the well will yield sand-free water. Redevelopment increases the effective radius of the well and, consequently, its yield.
2. 3. 4. 5.
3.8.7.2 Methods of Redevelopment Following are the methods of well redevelopment : i) ii) Over-pumping with pump. Surging with surge block and bailing.
47
Surging and pumping with air compressor. Back-washing. High-velocity jetting. Dynamiting and acid treatment.
For rehabilitation purpose any suitable method of redevelopment can be used as mentioned above. The largely used method is surging and pumping with compressed air. In this method surging with compressed air is a combination of surging and pumping. In the process a large volume of air is released suddenly into the well casing pipe, which produces a strong surge. Pumping is done with an ordinary air lift pump. To achieve successful redevelopment of the well the submergence ratio (along with two airlines in water divided by its total length) is important. For obtaining the best results the ideal submergence ratio should be about 60%. The efficiency of development reduces rapidly if the desired submergence ratio is not maintained. The equipment required for surging and pumping operation consist of an air compressor and a tank of required size, drop pipe and an airline with a suitable arrangements for raising and lowering each independently, flexible high pressure air hose for the supply of compressed air to the air pipe, pressure gauge, relief valve, a quick opening wall in the outlet of the tank, tee joint and pipe jointing material. Normally, air compressors of 500 cum. per hour at 7kg/cm2 to 800 cum. per hour at 17kgs/ cm2 are used for development/redevelopment work of the tubewell. Whenever under capacity air compressor is used for the development of the well, in such condition proper development is not possible and such wells become sick after a short period of use. These tubewells can only be rehabilitated by adopting the procedure of development of well which is known as redevelopment of the well. 3.8.7.3 Submergence Requirement of the Airline and Selection of Air Compressor Submergence Requirements of the Airline For achieving successful development/redevelopment of a well, submergence requirement of the airline is given below in table 3.2.
TABLE 3.2
Lift m 6 10 15 20 25 30 40 50 60 70 Maximum submergence % 70 70 70 70 70 70 65 65 60 55 Optimum submergence % 66 66 66 64 63 60 60 60 50 50 Minimum submergence % 55 55 50 50 50 45 45 45 40 40
48
3.8.7.4 Selection of Air-Compressor The two most important factors in the selection of an air compressor for well development/ redevelopment are the requirement of pressure and capacity. The required air pressure is determined, based on the length of air pipe below the static water level. Before air can be discharged from the lower end of the air pipe, the compressed air must push all the water out of the pipe. To do this, the air pressure must be greater than the water pressure before starting to pump water. The required pressure of compressor will be slightly more than submergence of the airline in the water. A useful rule of thumb to estimate the compressor capacity is to provide about 0.28 m3/l of free air for each litre per minute of water at the anticipated pumping rate. 3.8.7.5 Redevelopment Procedure For redevelopment of the tube well following steps are to be followed: Lower the drop pipe and air line in the well up to the desired submergence. The bottom of the drop pipe should be kept about 60cm above the bottom of the screen and the air line is kept about 30cm higher than the bottom end of the drop pipe. Turn on the air from the compressor and the well pumped by the conventional air lift principle until the discharge water is free from sand. Air entry into the well is then cut off by closing the valve between the tank and the compressor and in the meantime, the air line is lowered so that it is about 30cm below the bottom of the drop pipe. The airline is thus at the same position as in the backwashing method. The air valve is quickly opened to allow the compressed air from the tank into the well. This tends to surge water outwards through the well screen openings. The air pipe is raised again and the cycle repeated until the water discharged from the well is relatively free of sand. The above operation of back-washing and pumping completes one operation of surging. The entire assembly is then raised to a height of about one metre and the operations repeated until the well section along the entire length of the screen has been developed. Finally, the air pipe is lowered again to the bottom of the well and the equipment operated as a pump to flush out any sand that might have accumulated inside the screen.
Normally, with this method of redevelopment all the wells drilled in alluvial formation with inadequate development can be successfully redeveloped. This method has also been tried for sick wells drilled in rocky formations and encouraging results have been noticed. The use of disbursing agents like Polyphosphates have also been found useful in rehabilitating the wells with redevelopment method drilled in alluvial formation with inadequate development.
49
In case of the sacrificial anode system of cathodic protection, a metal of higher negative potential than that of the material of the pipe to be protected is used as the anode. The metal pipe acts as the Cathode and the intervening water as electrolyte (Fig. 3.4), thus establishing the flow of electrons from the anode to this cathode. During electrolysis, the anode gets dissolved slowly and the metal ions in the solution are deposited at the Cathode. Thus, the main pipe (well pipe) is protected from corrosion by sacrificing the metal of the anode. Sacrificial anodes are easy to install and no power costs are involved. They are effective in prolonging the service life of mild steel tube wells in corrosive water. However, the anodes have to be replaced periodically at the end of their useful life.
50
The anodes may be made of magnesium, zinc, aluminium, tin or their alloys. They are commercially available* in diameters ranging from 1.5 to 8 cm and lengths of 1 to 3 m. Research findings have established the adaptability of Aluminium-zinc-tin alloy in the cathodic protection of tube wells (a commonly used alloy has Al 90%, Zn 7% and Sn 3%). Alloys cast in steel core pipes of 1 cm diameter are also available. The anode rods are threaded at their ends for jointing with each other through sockets or couplings. (b) Impressed Current: In the Impressed current method electric current is passed from current source through anodes buried in the soil some distance from a mild steel pipeline. This method is extensively used in protecting mild steel pipelines in water supply projects but its applicability in wells has not yet been established.
51
ii) iii)
Loose stone check dams (LSCD) Dams Tank Ponds Recharge of wells Through injected wells Through roof top rain water harvesting structures
Direct recharge
WELL PROBLEMS AND THEIR SUGGESTED SOLUTIONS These are given in Annexure 3.1 and 3.2.
52
ANNEXURE: 3.1
(i) 1. 2. Dug well with or without ** steining Dug cum bore wells (i) With PVC casing (ii) With MS casing Cavity bores (i) With PVC casing (ii) With MS casing Infiltration galleries (i) Lined with brick masonry (ii) Lined with nonmetallic perforated pipes (iii) Lined with nonferrous metallic perforated pipes (iv) Lined with M.S. perforated pipes Radial collector wells (i) Radial with nonmetallic perforated pipes (ii) Radial with NonFerrous metallic perforated pipes (iii) Radial with M.S. perforated pipes Tubewells (borewells) (i) With PVC casing & screen pipes (ii) With M.S. casing & screen pipes Borewells
(ii)
(iii)
(iv)
(v)
(vi)
(vii)
**
**
**
** ** ** **
** ** ** **
**
** ** ** **
** ** ** **
** ** ** **
** ** ** **
3.
**
4.
** **
** **
** **
** **
**
** **
**
**
**
**
**
**
**
**
**
**
**
**
**
5.
**
**
**
**
**
**
**
**
**
**
**
**
**
**
**
**
**
**
**
6.
** ** **
** ** ** **
** ** **
** ** **
** ** **
** ** **
** ** **
7.
53
ANNEXURE: 3.2
2.
1. Over pumping 2. Adverse aquifer conditions 3. Falling of foreign objects in the bore
3.
Cavity bore
1. Bore silting 2. Decrease in yield 3. Mechanical failure 1. Silting in well caisson/Sump well 2. Decrease in yield
1. Over pumping 2. Adverse aquifer conditions 3. Falling of foreign objects in the bore 4. Collapse of cavity 1. Over pumping 2. Adverse aquifer conditions 3. Incrustation of radials 4. Blocking of screens with sand 5. Damage of M.S. screens due to corrosion. 1. Over pumping 2. Adverse aquifer conditions 3. Incrustation of screens & aquifers 4. Falling of foreign objects in the bore 5. Damage of M.S. screens due to corrosion. 1. Over pumping 2. Adverse aquifer conditions 3. Incrustation and silting of fractures & fissures. 4. Falling of foreign objects in the bore
4.
5.
Tube well
6.
Borewell
54