2532201-Book Page I Thursday, August 1, 1996 8:17 AM

SEA-DOO
SPECIFICATION
BOOKLET

1988-1996

(SMT-9601)

219 100 039

2532201-Book Page II Thursday, August 1, 1996 8:17 AM

INTRODUCTION
The purpose of this manual is to facilitate access to watercraft specifications.
Specifications which are more commonly used for the maintenance and repair of the different Sea-Doo watercraft for
the years specified on cover page, are grouped in sections.
This edition was primarily published to be used by watercraft
technicians who are already familiar with all service and
maintenance procedures relating to Bombardier watercraft.
NOTICE: Bombardier Inc. is not responsible for typesetting
errors.
The contents of this booklet is applicable to the particular
product at its time of manufacture. However it may include
later component improvements authorized by Bombardier.
See footnotes and read all appropriate bulletins.
The use of genuine Bombardier parts is strongly recommended when considering replacement of any component.
Dealer and / or distributor assistance should be sought in
case of doubt.
Torque tightening specifications must be strictly adhered to.
Locking devices (ex. : lock nut, locking disks, etc.) must be
installed or replaced with new ones, where specified. If the
efficiency of a locking device is impaired, it must be
renewed.
Bombardier Inc. disclaims liability for all damages and / or
injuries resulting from the improper use of the contents. We
strongly recommend that any service be carried out and / or
verified by a highly-skilled professional technician. It is understood that certain modifications may render the use of the
watercraft illegal under existing federal, provincial and state
regulations.

Bombardier Inc. reserves the right at any time to discontinue

or change specifications, designs, features, models or equipment without incurring obligation.

II

2532201-Book Page 1 Thursday, August 1, 1996 8:17 AM

MANUAL SECTIONS
PAGE
MODEL IDENTIFICATION ........

3-6

ENGINE ....................................

7-27

CARBURETION ........................

29-48

ELECTRICAL SYSTEM .............

49-68

PROPULSION ...........................

69-89

DIMENSIONS / CAPACITIES ....

MATERIALS .............................

91-109
111-129

TIGHTENING TORQUES
Engine ......................................
Propulsion and steering .........

131-149
151-169

MISCELLANEOUS ...................

171-178

2532201-Book Page 2 Thursday, August 1, 1996 8:17 AM

2532201-Book Page 3 Thursday, August 1, 1996 8:17 AM

SECTION CONTENTS

MODEL IDENTIFICATION

HULL IDENTIFICATION NUMBER . . . . . . . . . . . . . . . . . . . . . . . . . .

PAGE
4

MODEL IDENTIFICATION (BY MODEL-YEAR) . . . . . . . . . . . . . . . .

MODEL IDENTIFICATION (BY MODEL NUMBER) . . . . . . . . . . . . .

2532201-Book Page 4 Thursday, August 1, 1996 8:17 AM

MODEL IDENTIFICATION

SEA-DOO

HULL IDENTIFICATION NUMBER

ZZN1*23 4 5 L 4 9 5
Serial
number

Model year
Year of production
Month of production

*This digit may be a number or a letter.

MODEL IDENTIFICATION (BY MODEL-YEAR)

MODEL NAME

MODEL
NO.

1996
SP . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
SPX . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
SPI . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
XP . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
XP (P.D.I. Ready) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
GSX . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
GTS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
GTI . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
GTI (Touring Seat) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
GTI (single carb) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
GTX . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
HX . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

5876
5877
5878
5858
5859
5620
5817
5865
5866
5867
5640
5881

1995
SP . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
SPX . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
SPI . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
XP 800 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
XP . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
GTS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
GTS (Touring Seat) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
GTX . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
GTX (Touring Seat) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
HX . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

5873
5874
5875
5856
5857
5815
5816
5863
5864
5880

2532201-Book Page 5 Thursday, August 1, 1996 8:17 AM

1994
SP . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
SPX . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
SPI . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
XP . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
XP . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
GTS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
GTX . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

5870
5871
5872
5854
5855
5814
5862

1993
SP . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
SPX . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
SPI . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
XP . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
GTS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
GTX . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

5806
5807
5808
5852
5813
5861

1992
SP . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
XP . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
GTS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
GTX . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

5805
5851
5812
5860

1991
SP . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
XP . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
GT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

5804
5850
5811

1990
SP . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
GT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

5803
5810

1989
SP . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

5802

1988
SP . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

5801

2532201-Book Page 6 Thursday, August 1, 1996 8:17 AM

MODEL IDENTIFICATION (BY MODEL NUMBER)

MODEL NUMBER

MODEL YEAR

MODEL NAME

5620
5640
5801
5802
5803
5804
5805
5806
5807
5808
5810
5811
5812
5813
5814
5815
5816
5817
5850
5851
5852
5854
5855
5856
5857
5858
5859
5860
5861
5862
5863
5864
5865
5866
5867
5870
5871
5872
5873
5874
5875
5876
5877
5878
5880
5881

1996
1996
1988
1989
1990
1991
1992
1993
1993
1993
1990
1991
1992
1993
1994
1995
1995
1996
1991
1992
1993
1994
1994
1995
1995
1996
1996
1992
1993
1994
1995
1995
1996
1996
1996
1994
1994
1994
1995
1995
1995
1996
1996
1996
1995
1996

GSX
GTX
SP
SP
SP
SP
SP
SP
SPX
SPI
GT
GT
GTS
GTS
GTS
GTS
GTS (Touring Seat)
GTS
XP
XP
XP
XP
XP
XP 800
XP
XP
XP (P.D.I. Ready)
GTX
GTX
GTX
GTX
GTX (Touring Seat)
GTI
GTI (Touring Seat)
GTI (single carb)
SP
SPX
SPI
SP
SPX
SPI
SP
SPX
SPI
HX
HX

.....................
.....................
.....................
.....................
.....................
.....................
.....................
.....................
.....................
.....................
.....................
.....................
.....................
.....................
.....................
.....................
.....................
.....................
.....................
.....................
.....................
.....................
.....................
.....................
.....................
.....................
.....................
.....................
.....................
.....................
.....................
.....................
.....................
.....................
.....................
.....................
.....................
.....................
.....................
.....................
.....................
.....................
.....................
.....................
.....................
.....................

...............
...............
...............
...............
...............
...............
...............
...............
...............
...............
...............
...............
...............
...............
...............
...............
...............
...............
...............
...............
...............
...............
...............
...............
...............
...............
...............
...............
...............
...............
...............
...............
...............
...............
...............
...............
...............
...............
...............
...............
...............
...............
...............
...............
...............
...............

2532201-Book Page 7 Thursday, August 1, 1996 8:17 AM

SECTION CONTENTS

ENGINE

TABLE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

PAGE
8

Engine Type
Bore
Stroke
Displacement
Compression Ratio (Corrected)
Ring End Gap
Piston / Cylinder Wall Clearance
Cylinder Taper (Maximum)
Cylinder Out of Round (Maximum)
Connecting Rod Big End Axial Play
Rotary Valve Duration
Rotary Valve Timing
Rotary Valve / Cover Clearance
ABBREVIATIONS:
N: New = Minimum Allowable
U: Used = Wear Limit

DISPLACEMENT

mm
(in)

cm3
(in3)

RING END GAP

STROKE

mm
(in)

COMPRESSION
RATIO
(CORRECTED)

BORE

ENGINE TYPE

2532201-Book Page 8 Thursday, August 1, 1996 8:17 AM

N/U
mm
(in)

1996
SP
(5876)

587

76
(2.992)

64
(2.520)

580.7
(35.4)

6.5 : 1

0.25
(.010)
1.00
(.039)

SPX
(5877)

717

82
(3.228)

68
(2.68)

718.2
(43.82)

6.2 : 1

0.25
(.010)
1.00
(.039)

SPI
(5878)

587

76
(2.992)

64
(2.520)

580.7
(35.4)

6.5 : 1

0.25
(.010)
1.00
(.039)

XP
(5858 / 5859)

787

82
(3.228)

74
(2.91)

781.6
(47.7)

5.9 : 1

0.25
(.010)
1.00
(.039)

GSX
(5620)

787

82
(3.228)

74
(2.91)

781.6
(47.7)

5.9 : 1

0.25
(.010)
1.00
(.039)

GTS
(5817)

587

76
(2.992)

64
(2.520)

580.7
(35.4)

6.5 : 1

0.25
(.010)
1.00
(.039)

GTI
(5865 / 5866 /
5867)

717

82
(3.228)

68
(2.68)

718.2
(43.82)

6.2 : 1

0.25
(.010)
1.00
(.039)

GTX
(5640)

787

82
(3.228)

74
(2.91)

781.6
(47.7)

5.9 : 1

0.25
(.010)
1.00
(.039)

CONNECTING
ROD BIG END
AXIAL PLAY

mm
(in)

N/U
mm
(in)

0.05
(.002)
0.2
(.008)

0.100
(.004)

0.080
(.003)

0.39
(.015)
1.2
(.047)

0.060
(.0023)
0.2
(.008)

0.100
(.004)

0.080
(.003)

0.05
(.002)
0.2
(.008)

0.100
(.004)

0.100
(.0039)
0.2
(.008)

ROTARY
VALVE /
COVER
CLEARANCE

CYLINDER OUT
OF ROUND
(MAXIMUM)

mm
(in)

ROTARY VALVE
TIMING

CYLINDER TAPER
(MAXIMUM)

N/U
mm
(in)

ROTARY VALVE
DURATION

PISTON /
CYLINDER WALL
CLEARANCE

2532201-Book Page 9 Thursday, August 1, 1996 8:17 AM

opening /
closing

mm
(in)

147

130
65

0.25 - 0.35
(.010 - .014)

0.39
(.015)
1.2
(.047)

159

147
65.5

0.25 - 0.35
(.010 - .014)

0.080
(.003)

0.39
(.015)
1.2
(.047)

147

130
65

0.25 - 0.35
(.010 - .014)

0.100
(.004)

0.080
(.003)

0.39
(.015)
1.2
(.047)

159

146.5
64

0.25 - 0.35
(.010 - .014)

0.100
(.0039)
0.2
(.008)

0.100
(.004)

0.080
(.003)

0.39
(.015)
1.2
(.047)

159

146.5
64

0.25 - 0.35
(.010 - .014)

0.05
(.002)
0.2
(.008)

0.100
(.004)

0.080
(.003)

0.39
(.015)
1.2
(.047)

147

130
65

0.25 - 0.35
(.010 - .014)

0.060
(.0023)
0.2
(.008)

0.100
(.004)

0.080
(.003)

0.39
(.015)
1.2
(.047)

159

147
65.5

0.25 - 0.35
(.010 - .014)

0.100
(.0039)
0.2
(.008)

0.100
(.004)

0.080
(.003)

0.39
(.015)
1.2
(.047)

159

146.5
64

0.25 - 0.35
(.010 - .014)

10

mm
(in)

cm3
(in3)

82
(3.228)

68
(2.68)

718.2
(43.82)

RING END GAP

mm
(in)

COMPRESSION
RATIO
(CORRECTED)

DISPLACEMENT

717

STROKE

HX
(5881)

BORE

ENGINE TYPE

2532201-Book Page 10 Thursday, August 1, 1996 8:17 AM

N/U
mm
(in)

6.2 : 1

0.25
(.010)
1.00
(.039)

CONNECTING
ROD BIG END
AXIAL PLAY

mm
(in)

N/U
mm
(in)

0.100
(.004)

0.080
(.003)

0.060
(.0023)
0.2
(.008)

0.39
(.015)
1.2
(.047)

159

ROTARY
VALVE /
COVER
CLEARANCE

CYLINDER OUT
OF ROUND
(MAXIMUM)

mm
(in)

ROTARY VALVE
TIMING

CYLINDER TAPER
(MAXIMUM)

N/U
mm
(in)

ROTARY VALVE
DURATION

PISTON /
CYLINDER WALL
CLEARANCE

2532201-Book Page 11 Thursday, August 1, 1996 8:17 AM

opening /
closing

mm
(in)

147
65.5

0.25 - 0.35
(.010 - .014)

11

DISPLACEMENT

mm
(in)

cm3
(in3)

RING END GAP

STROKE

mm
(in)

COMPRESSION
RATIO
(CORRECTED)

BORE

ENGINE TYPE

2532201-Book Page 12 Thursday, August 1, 1996 8:17 AM

N/U
mm
(in)

1995
SP
(5873)

587

76
(2.992)

64
(2.520)

580.7
(35.4)

5.9 : 1

0.25
(.010)
1.00
(.039)

SPX
(5874)

657 X

78
(3.071)

68
(2.68)

650
(39.67)

6.4 : 1

0.25
(.010)
1.00
(.039)

SPI
(5875)

587

76
(2.992)

64
(2.520)

580.7
(35.4)

5.9 : 1

0.25
(.010)
1.00
(.039)

XP 800
(5856)

787

82
(3.228)

74
(2.91)

781.6
(47.7)

5.9 : 1

0.25
(.010)
1.00
(.039)

XP
(5857)

717

82
(3.228)

68
(2.68)

718
(43.81)

6.4 : 1

0.25
(.010)
1.00
(.039)

GTS
(5815 / 5816)

587

76
(2.992)

64
(2.520)

580.7
(35.4)

5.9 : 1

0.25
(.010)
1.00
(.039)

GTX
(5863 / 5864)

657 X

78
(3.071)

68
(2.68)

650
(39.67)

6.4 : 1

0.25
(.010)
1.00
(.039)

HX
(5880)

717

82
(3.228)

68
(2.68)

718
(43.81)

6.4 : 1

0.25
(.010)
1.00
(.039)

12

CONNECTING
ROD BIG END
AXIAL PLAY

mm
(in)

N/U
mm
(in)

0.05
(.002)
0.2
(.008)

0.100
(.004)

0.080
(.003)

0.39
(.015)
1.2
(.047)

0.093
(.0036)
0.2
(.008)

0.100
(.004)

0.080
(.003)

0.05
(.002)
0.2
(.008)

0.100
(.004)

0.093
(.0036)
0.2
(.008)

ROTARY
VALVE /
COVER
CLEARANCE

CYLINDER OUT
OF ROUND
(MAXIMUM)

mm
(in)

ROTARY VALVE
TIMING

CYLINDER TAPER
(MAXIMUM)

N/U
mm
(in)

ROTARY VALVE
DURATION

PISTON /
CYLINDER WALL
CLEARANCE

2532201-Book Page 13 Thursday, August 1, 1996 8:17 AM

opening /
closing

mm
(in)

147

130
65

0.25 - 0.35
(.010 - .014)

0.39
(.015)
1.2
(.047)

159

147
65

0.25 - 0.35
(.010 - .014)

0.080
(.003)

0.39
(.015)
1.2
(.047)

147

130
65

0.25 - 0.35
(.010 - .014)

0.100
(.004)

0.080
(.003)

0.39
(.015)
1.2
(.047)

159

147
65

0.25 - 0.35
(.010 - .014)

0.093
(.0036)
0.2
(.008)

0.100
(.004)

0.080
(.003)

0.39
(.015)
1.2
(.047)

159

147
65

0.25 - 0.35
(.010 - .014)

0.05
(.002)
0.2
(.008)

0.100
(.004)

0.080
(.003)

0.39
(.015)
1.2
(.047)

147

130
65

0.25 - 0.35
(.010 - .014)

0.093
(.0036)
0.2
(.008)

0.100
(.004)

0.080
(.003)

0.39
(.015)
1.2
(.047)

159

147
65

0.25 - 0.35
(.010 - .014)

0.093
(.0036)
0.2
(.008)

0.100
(.004)

0.080
(.003)

0.39
(.015)
1.2
(.047)

159

147
65

0.25 - 0.35
(.010 - .014)

13

DISPLACEMENT

mm
(in)

cm3
(in3)

RING END GAP

STROKE

mm
(in)

COMPRESSION
RATIO
(CORRECTED)

BORE

ENGINE TYPE

2532201-Book Page 14 Thursday, August 1, 1996 8:17 AM

N/U
mm
(in)

1994

14

SP
(5870)

587

76
(2.992)

64
(2.520)

580.7
(35.4)

5.9 : 1

0.25
(.010)
1.00
(.039)

SPX
(5871)

657

78
(3.071)

68
(2.68)

650
(39.67)

6.9 : 1

0.25
(.010)
1.00
(.039)

SPI
(5872)

587

76
(2.992)

64
(2.520)

580.7
(35.4)

5.9 : 1

0.25
(.010)
1.00
(.039)

XP
(5854)

657 X

78
(3.071)

68
(2.68)

650
(39.67)

6.4 : 1

0.25
(.010)
1.00
(.039)

XP
(5855)

657

78
(3.071)

68
(2.68)

650
(39.67)

6.9 : 1

0.25
(.010)
1.00
(.039)

GTS
(5814)

587

76
(2.992)

64
(2.520)

580.7
(35.4)

5.9 : 1

0.25
(.010)
1.00
(.039)

GTX
(5862)

657

78
(3.071)

68
(2.68)

650
(39.67)

6.9 : 1

0.25
(.010)
1.00
(.039)

CONNECTING
ROD BIG END
AXIAL PLAY

mm
(in)

N/U
mm
(in)

0.05
(.002)
0.2
(.008)

0.08
(.003)

0.05
(.002)

0.39
(.015)
1.2
(.047)

0.05
(.002)
0.15
(.006)

0.08
(.003)

0.05
(.002)

0.05
(.002)
0.2
(.008)

0.08
(.003)

0.05
(.002)
0.15
(.006)

ROTARY
VALVE /
COVER
CLEARANCE

CYLINDER OUT
OF ROUND
(MAXIMUM)

mm
(in)

ROTARY VALVE
TIMING

CYLINDER TAPER
(MAXIMUM)

N/U
mm
(in)

ROTARY VALVE
DURATION

PISTON /
CYLINDER WALL
CLEARANCE

2532201-Book Page 15 Thursday, August 1, 1996 8:17 AM

opening /
closing

mm
(in)

147

130
65

0.25 - 0.35
(.010 - .014)

0.39
(.015)
1.2
(.047)

147

130
65

0.25 - 0.35
(.010 - .014)

0.05
(.002)

0.39
(.015)
1.2
(.047)

147

130
65

0.25 - 0.35
(.010 - .014)

0.08
(.003)

0.05
(.002)

0.39
(.015)
1.2
(.047)

159

149
65

0.25 - 0.35
(.010 - .014)

0.05
(.002)
0.15
(.006)

0.08
(.003)

0.05
(.002)

0.39
(.015)
1.2
(.047)

147

130
65

0.25 - 0.35
(.010 - .014)

0.05
(.002)
0.2
(.008)

0.08
(.003)

0.05
(.002)

0.39
(.015)
1.2
(.047)

147

130
65

0.25 - 0.35
(.010 - .014)

0.05
(.002)
0.15
(.006)

0.08
(.003)

0.05
(.002)

0.39
(.015)
1.2
(.047)

147

130
65

0.25 - 0.35
(.010 - .014)

15

DISPLACEMENT

mm
(in)

cm3
(in3)

RING END GAP

STROKE

mm
(in)

COMPRESSION
RATIO
(CORRECTED)

BORE

ENGINE TYPE

2532201-Book Page 16 Thursday, August 1, 1996 8:17 AM

N/U
mm
(in)

1993

16

SP
(5806)

587

76
(2.992)

64
(2.520)

580.7
(35.4)

6.5 : 1

0.25
(.010)
1.00
(.039)

SPX
(5807)

587

76
(2.992)

64
(2.520)

580.7
(35.4)

6.5 : 1

0.25
(.010)
1.00
(.039)

SPI
(5808)

587

76
(2.992)

64
(2.520)

580.7
(35.4)

6.5 : 1

0.25
(.010)
1.00
(.039)

XP
(5852)

657

78
(3.071)

68
(2.68)

650
(39.67)

6.7 : 1

0.25
(.010)
1.00
(.039)

GTS
(5813)

587

76
(2.992)

64
(2.520)

580.7
(35.4)

6.5 : 1

0.25
(.010)
1.00
(.039)

GTX
(5861)

587

76
(2.992)

64
(2.520)

580.7
(35.4)

6.5 : 1

0.25
(.010)
1.00
(.039)

CONNECTING
ROD BIG END
AXIAL PLAY

mm
(in)

N/U
mm
(in)

0.05
(.002)
0.2
(.008)

0.08
(.003)

0.05
(.002)

0.39
(.015)
1.2
(.047)

0.05
(.002)
0.2
(.008)

0.08
(.003)

0.05
(.002)

0.05
(.002)
0.2
(.008)

0.08
(.003)

0.06
(.003)
0.15
(.006)

ROTARY
VALVE /
COVER
CLEARANCE

CYLINDER OUT
OF ROUND
(MAXIMUM)

mm
(in)

ROTARY VALVE
TIMING

CYLINDER TAPER
(MAXIMUM)

N/U
mm
(in)

ROTARY VALVE
DURATION

PISTON /
CYLINDER WALL
CLEARANCE

2532201-Book Page 17 Thursday, August 1, 1996 8:17 AM

opening /
closing

mm
(in)

147

115
80

0.25 - 0.35
(.010 - .014)

0.39
(.015)
1.2
(.047)

147

130
65

0.25 - 0.35
(.010 - .014)

0.05
(.002)

0.39
(.015)
1.2
(.047)

147

115
80

0.25 - 0.35
(.010 - .014)

0.08
(.003)

0.05
(.002)

0.39
(.015)
1.2
(.047)

147

130
65

0.25 - 0.35
(.010 - .014)

0.05
(.002)
0.2
(.008)

0.08
(.003)

0.05
(.002)

0.39
(.015)
1.2
(.047)

147

115
80

0.25 - 0.35
(.010 - .014)

0.05
(.002)
0.2
(.008)

0.08
(.003)

0.05
(.002)

0.39
(.015)
1.2
(.047)

147

130
65

0.25 - 0.35
(.010 - .014)

17

DISPLACEMENT

mm
(in)

cm3
(in3)

RING END GAP

STROKE

mm
(in)

COMPRESSION
RATIO
(CORRECTED)

BORE

ENGINE TYPE

2532201-Book Page 18 Thursday, August 1, 1996 8:17 AM

N/U
mm
(in)

1992

18

SP
(5805)

587

76
(2.992)

64
(2.520)

580.7
(35.4)

5.9 : 1

0.25
(.010)
1.00
(.039)

XP
(5851)

587

76
(2.992)

64
(2.520)

580.7
(35.4)

5.9 : 1

0.25
(.010)
1.00
(.039)

GTS
(5812)

587

76
(2.992)

64
(2.520)

580.7
(35.4)

5.9 : 1

0.25
(.010)
1.00
(.039)

GTX
(5860)

587

76
(2.992)

64
(2.520)

580.7
(35.4)

5.9 : 1

0.25
(.010)
1.00
(.039)

CONNECTING
ROD BIG END
AXIAL PLAY

mm
(in)

N/U
mm
(in)

0.05
(.002)
0.2
(.008)

0.08
(.003)

0.05
(.002)

0.39
(.015)
1.2
(.047)

0.05
(.002)
0.2
(.008)

0.08
(.003)

0.05
(.002)

0.05
(.002)
0.2
(.008)

0.08
(.003)

0.05
(.002)
0.2
(.008)

0.08
(.003)

ROTARY
VALVE /
COVER
CLEARANCE

CYLINDER OUT
OF ROUND
(MAXIMUM)

mm
(in)

ROTARY VALVE
TIMING

CYLINDER TAPER
(MAXIMUM)

N/U
mm
(in)

ROTARY VALVE
DURATION

PISTON /
CYLINDER WALL
CLEARANCE

2532201-Book Page 19 Thursday, August 1, 1996 8:17 AM

opening /
closing

mm
(in)

147

115
80

0.22 - 0.35
(.009 - .014)

0.39
(.015)
1.2
(.047)

147

130
65

0.22 - 0.35
(.009 - .014)

0.05
(.002)

0.39
(.015)
1.2
(.047)

147

115
80

0.22 - 0.35
(.009 - .014)

0.05
(.002)

0.39
(.015)
1.2
(.047)

147

130
65

0.22 - 0.35
(.009 - .014)

19

DISPLACEMENT

mm
(in)

cm3
(in3)

RING END GAP

STROKE

mm
(in)

COMPRESSION
RATIO
(CORRECTED)

BORE

ENGINE TYPE

2532201-Book Page 20 Thursday, August 1, 1996 8:17 AM

N/U
mm
(in)

1991

20

SP
(5804)

587

76
(2.992)

64
(2.520)

580.7
(35.4)

5.9 : 1

0.25
(.010)
1.00
(.039)

XP
(5850)

587

76
(2.992)

64
(2.520)

580.7
(35.4)

5.9 : 1

0.25
(.010)
1.00
(.039)

GT
(5811)

587

76
(2.992)

64
(2.520)

580.7
(35.4)

5.9 : 1

0.25
(.010)
1.00
(.039)

CONNECTING
ROD BIG END
AXIAL PLAY

mm
(in)

N/U
mm
(in)

0.06
(.002)
0.2
(.008)

0.08
(.003)

0.05
(.002)

0.4
(.016)
1.2
(.047)

0.06
(.002)
0.2
(.008)

0.08
(.003)

0.05
(.002)

0.06
(.002)
0.2
(.008)

0.08
(.003)

0.05
(.002)

ROTARY
VALVE /
COVER
CLEARANCE

CYLINDER OUT
OF ROUND
(MAXIMUM)

mm
(in)

ROTARY VALVE
TIMING

CYLINDER TAPER
(MAXIMUM)

N/U
mm
(in)

ROTARY VALVE
DURATION

PISTON /
CYLINDER WALL
CLEARANCE

2532201-Book Page 21 Thursday, August 1, 1996 8:17 AM

opening /
closing

mm
(in)

147

115
80

0.20 - 0.30
(.008 - .013)

0.4
(.016)
1.2
(.047)

132

115
65

0.20 - 0.30
(.008 - .013)

0.4
(.016)
1.2
(.047)

132

115
65

0.20 - 0.30
(.008 - .013)

21

DISPLACEMENT

mm
(in)

cm3
(in3)

RING END GAP

STROKE

mm
(in)

COMPRESSION
RATIO
(CORRECTED)

BORE

ENGINE TYPE

2532201-Book Page 22 Thursday, August 1, 1996 8:17 AM

N/U
mm
(in)

1990

22

SP
(5803)

587

76
(2.992)

64
(2.520)

580.7
(35.4)

5.9 : 1

0.25
(.010)
1.00
(.039)

GT
(5810)

587

76
(2.992)

64
(2.520)

580.7
(35.4)

5.9 : 1

0.25
(.010)
1.00
(.039)

CONNECTING
ROD BIG END
AXIAL PLAY

mm
(in)

N/U
mm
(in)

0.06
(.002)
0.2
(.008)

0.08
(.003)

0.05
(.002)

0.4
(.016)
1.2
(.047)

0.06
(.002)
0.2
(.008)

0.08
(.003)

0.05
(.002)

0.4
(.016)
1.2
(.047)

ROTARY
VALVE /
COVER
CLEARANCE

CYLINDER OUT
OF ROUND
(MAXIMUM)

mm
(in)

ROTARY VALVE
TIMING

CYLINDER TAPER
(MAXIMUM)

N/U
mm
(in)

ROTARY VALVE
DURATION

PISTON /
CYLINDER WALL
CLEARANCE

2532201-Book Page 23 Thursday, August 1, 1996 8:17 AM

opening /
closing

mm
(in)

132

132
52

0.30 - 0.50
(.012 - .020)

132

132
52

0.30 - 0.50
(.012 - .020)

23

DISPLACEMENT

mm
(in)

cm3
(in3)

76
(2.992)

64
(2.520)

580.7
(35.4)

RING END GAP

STROKE

mm
(in)

COMPRESSION
RATIO
(CORRECTED)

BORE

ENGINE TYPE

2532201-Book Page 24 Thursday, August 1, 1996 8:17 AM

N/U
mm
(in)

1989
SP
(5802)

24

587

5.9 : 1

0.25
(.010)
1.00
(.039)

CONNECTING
ROD BIG END
AXIAL PLAY

mm
(in)

N/U
mm
(in)

0.08
(.003)

0.05
(.002)

0.06
(.002)
0.2
(.008)

0.4
(.016)
1.2
(.047)

132

ROTARY
VALVE /
COVER
CLEARANCE

CYLINDER OUT
OF ROUND
(MAXIMUM)

mm
(in)

ROTARY VALVE
TIMING

CYLINDER TAPER
(MAXIMUM)

N/U
mm
(in)

ROTARY VALVE
DURATION

PISTON /
CYLINDER WALL
CLEARANCE

2532201-Book Page 25 Thursday, August 1, 1996 8:17 AM

opening /
closing

mm
(in)

132
52

0.30 - 0.50
(.012 - .020)

25

DISPLACEMENT

mm
(in)

cm3
(in3)

76
(2.992)

64
(2.520)

580.7
(35.4)

RING END GAP

STROKE

mm
(in)

COMPRESSION
RATIO
(CORRECTED)

BORE

ENGINE TYPE

2532201-Book Page 26 Thursday, August 1, 1996 8:17 AM

N/U
mm
(in)

1988
SP
(5801)

26

587

5.9 : 1

0.25
(.010)
1.00
(.039)

CONNECTING
ROD BIG END
AXIAL PLAY

mm
(in)

N/U
mm
(in)

0.08
(.003)

0.05
(.002)

0.06
(.002)
0.2
(.008)

0.4
(.016)
1.2
(.047)

132

ROTARY
VALVE /
COVER
CLEARANCE

CYLINDER OUT
OF ROUND
(MAXIMUM)

mm
(in)

ROTARY VALVE
TIMING

CYLINDER TAPER
(MAXIMUM)

N/U
mm
(in)

ROTARY VALVE
DURATION

PISTON /
CYLINDER WALL
CLEARANCE

2532201-Book Page 27 Thursday, August 1, 1996 8:17 AM

opening /
closing

mm
(in)

132
52

0.30 - 0.50
(.012 - .020)

27

2532201-Book Page 28 Thursday, August 1, 1996 8:17 AM

28

2532201-Book Page 29 Thursday, August 1, 1996 8:17 AM

SECTION CONTENTS

CARBURETION

TABLE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

PAGE
30

Carburetor Type
Carburetor Quantity
Fuel Type
Minimum Fuel Octane
Main Jet
Pilot Jet
Low Speed Screw Adjustment
High Speed Screw Adjustment
Idle Speed (In Water)
Idle Speed (Out of Water)
Fuel Return Line Orifice
Pop Off Pressure
MAIN JET AND PILOT JET . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

48

ABBREVIATIONS:
MAG: Magneto Side
PTO: Power Take Off Side
N.A.: Not Applicable
Minimum fuel Octane= (RON + MON) / 2

29

CARBURETOR
QUANTITY

MINIMUM
FUEL OCTANE

MAIN JET

SP
(5876)

MIKUNI
BN-38
(DIAPHRAGM)

REGULAR
UNLEADED

87

142.5

SPX
(5877)

MIKUNI
BN-38I
(DIAPHRAGM)

REGULAR
UNLEADED

87

130

SPI
(5878)

MIKUNI
BN-38
(DIAPHRAGM)

REGULAR
UNLEADED

87

147.5

XP
(5858 / 5859)

MIKUNI
BN-40I
(DIAPHRAGM)

REGULAR
UNLEADED

87

142.5

GSX
(5620)

MIKUNI
BN-40I
(DIAPHRAGM)

REGULAR
UNLEADED

87

142.5

GTS
(5817)

MIKUNI
BN-38
(DIAPHRAGM)

REGULAR
UNLEADED

87

147.5

GTI
(5865 / 5866)

MIKUNI
BN-38I
(DIAPHRAGM)

REGULAR
UNLEADED

87

130

GTI
(5867)

MORGENROTH
44 mm

REGULAR
UNLEADED

87

N.A.

GTX
(5640)

MIKUNI
BN-40I
(DIAPHRAGM)

REGULAR
UNLEADED

87

142.5

HX
(5881)

MIKUNI
BN-38I
(DIAPHRAGM)

REGULAR
UNLEADED

87

130

FUEL TYPE

CARBURETOR
TYPE

2532201-Book Page 30 Thursday, August 1, 1996 8:17 AM

1996

30

FUEL RETURN
LINE ORIFICE

POP OFF
PRESSURE

RPM

IDLE SPEED
(OUT OF WATER)

IDLE SPEED
(IN WATER)

HIGH SPEED
SCREW
ADJUSTMENT

LOW SPEED
SCREW
ADJUSTMENT

PILOT JET

2532201-Book Page 31 Thursday, August 1, 1996 8:17 AM

RPM

mm
(in)

KPa
(PSI)

0.8
(.031)

145 - 255
(21 - 37)

1-1/4 1/4

1500

2400

67.5 1-1/4 1/4

1500

3000 MAG 0.8 (0.31) 276 - 386

PTO 0.8 (.031) (40 - 56)

65

1-1/4 1/4

1500

2500

70

1 1/4

1500

3000 MAG 0.8 (.031) 186 - 269

PTO 0.8 (.031) (27 - 39)

70

1 1/4

1500

3000 MAG 0.8 (.031) 186 - 269

PTO 0.8 (.031) (27 - 39)

65

1-1/4 1/4

1500

2500

67.5 1-1/4 1/4

1500

3000 MAG 0.8 (0.31) 276 - 386

PTO 0.8 (.031) (40 - 56)

65

0.8
(.031)

0.8
(.031)

0.8
(.031)

145 - 255
(21 - 37)

145 - 255
(21 - 37)

N.A.

N.A.

N.A.

1500

3000

N.A.

70

1 1/4

1500

3000 MAG 0.8 (0.31) 186 - 269

PTO 0.8 (.031) (27 - 39)

75

1-1/2 1/4

1500

3000 MAG 0.8 (.031) 275 - 385

PTO 0.8 (.031) (40 - 56)

31

CARBURETOR
QUANTITY

MINIMUM
FUEL OCTANE

MAIN JET

SP
(5873)

MIKUNI
BN-38
(DIAPHRAGM)

REGULAR
UNLEADED

87

142.5

SPX
(5874)

MIKUNI
BN-38I
(DIAPHRAGM)

REGULAR
UNLEADED

87

135

SPI
(5875)

MIKUNI
BN-38
(DIAPHRAGM)

REGULAR
UNLEADED

87

147.5

XP 800
(5856)

MIKUNI
BN-40I
(DIAPHRAGM)

REGULAR
UNLEADED

87

147.5

XP
(5857)

MIKUNI
BN-38I
(DIAPHRAGM)

REGULAR
UNLEADED

87

135

GTS
(5815 / 5816)

MIKUNI
BN-38
(DIAPHRAGM)

REGULAR
UNLEADED

87

147.5

GTX
(5863 / 5864)

MIKUNI
BN-38I
(DIAPHRAGM)

REGULAR
UNLEADED

87

132.5

HX
(5880)

MIKUNI
BN-38I
(DIAPHRAGM)

REGULAR
UNLEADED

87

135

FUEL TYPE

CARBURETOR
TYPE

2532201-Book Page 32 Thursday, August 1, 1996 8:17 AM

1995

32

FUEL RETURN
LINE ORIFICE

POP OFF
PRESSURE

RPM

IDLE SPEED
(OUT OF WATER)

IDLE SPEED
(IN WATER)

HIGH SPEED
SCREW
ADJUSTMENT

LOW SPEED
SCREW
ADJUSTMENT

PILOT JET

2532201-Book Page 33 Thursday, August 1, 1996 8:17 AM

RPM

mm
(in)

KPa
(PSI)

0.8
(.031)

145 - 255
(21 - 37)

1-1/4 1/4

1500

2400

72.5 1-1/8 1/8

1500

3000 MAG 3.0 (.118) 150 - 255

PTO 0.8 (.031) (22 - 37)

65

1-1/4 1/4

1500

2500

60

1 1/8

1500

3000 MAG 0.8 (.031) 275 - 385

PTO 0.8 (.031) (40 - 56)

67.5 1-3/4 1/4

1500

3000 MAG 0.8 (.031) 275 - 385

PTO 0.8 (.031) (40 - 56)

65

1-1/4 1/4

1500

2500

75

1-1/4 1/4

1/4

1500

3000 MAG 3.0 (.118) 130 - 240

PTO 0.8 (.031) (19 - 35)

1500

3000 MAG 0.8 (.031) 275 - 385

PTO 0.8 (.031) (40 - 56)

65

67.5 1-3/4 1/4

0.8
(.031)

0.8
(.031)

145 - 255
(21 - 37)

145 - 255
(21 - 37)

As per Predelivery Bulletin 95-8.

33

CARBURETOR
QUANTITY

MINIMUM
FUEL OCTANE

MAIN JET

SP
(5870)

MIKUNI
BN-38
(DIAPHRAGM)

REGULAR
UNLEADED

87

142.5

SPX
(5871)

MIKUNI
BN-38
(DIAPHRAGM)

REGULAR
UNLEADED

87

125

SPI
(5872)

MIKUNI
BN-38
(DIAPHRAGM)

REGULAR
UNLEADED

87

147.5

XP
(5854)

MIKUNI
BN-38I
(DIAPHRAGM)

REGULAR
UNLEADED

87

132.5

XP
(5855)

MIKUNI
BN-38
(DIAPHRAGM)

REGULAR
UNLEADED

87

125

GTS
(5814)

MIKUNI
BN-38
(DIAPHRAGM)

REGULAR
UNLEADED

87

147.5

GTX
(5862)

MIKUNI
BN-38
(DIAPHRAGM)

REGULAR
UNLEADED

87

125

FUEL TYPE

CARBURETOR
TYPE

2532201-Book Page 34 Thursday, August 1, 1996 8:17 AM

1994

34

FUEL RETURN
LINE ORIFICE

POP OFF
PRESSURE

RPM

IDLE SPEED
(OUT OF WATER)

IDLE SPEED
(IN WATER)

HIGH SPEED
SCREW
ADJUSTMENT

LOW SPEED
SCREW
ADJUSTMENT

PILOT JET

2532201-Book Page 35 Thursday, August 1, 1996 8:17 AM

RPM

mm
(in)

KPa
(PSI)

0.5
(.020)

150 - 200
(22 - 29)

65

1 1/4

1400

2400

60

1-1/4 1/4

3/8

1400

3000 MAG 3.0 (.118) 150 - 200

PTO 0.5 (.020) (22 - 29)

65

1 1/4

1400

2400

75

1-1/4 1/4

1500

3100 MAG 3.0 (.118) 110-145

PTO 0.5 (.020) (16-21)

60

1-1/4 1/4

3/8

1400

3000 MAG 3.0 (.118) 150 - 200

PTO 0.5 (.020) (22 - 29)

65

1 1/4

1400

2500

60

1-1/4 1/4

3/8

1400

2800 MAG 3.0 (.118) 150 - 200

PTO 0.5 (.020) (22 - 29)

0.5
(.020)

0.5
(.020)

150 - 200
(22 - 29)

150 - 200
(22 - 29)

As per Warranty Bulletin 94-5.

35

CARBURETOR
QUANTITY

MINIMUM
FUEL OCTANE

MAIN JET

SP
(5806)

MIKUNI
BN-38
(DIAPHRAGM)

REGULAR
UNLEADED

87

125

SPX
(5807)

MIKUNI
BN-38
(DIAPHRAGM)

REGULAR
UNLEADED

87

107.5

SPI
(5808)

MIKUNI
BN-38
(DIAPHRAGM)

REGULAR
UNLEADED

87

125

XP
(5852)

MIKUNI
BN-38
(DIAPHRAGM)

REGULAR
UNLEADED

87

125

GTS
(5813)

MIKUNI
BN-38
(DIAPHRAGM)

REGULAR
UNLEADED

87

125

GTX
(5861)

MIKUNI
BN-38
(DIAPHRAGM)

REGULAR
UNLEADED

87

107.5

FUEL TYPE

CARBURETOR
TYPE

2532201-Book Page 36 Thursday, August 1, 1996 8:17 AM

1993

36

POP OFF
PRESSURE

HIGH SPEED
SCREW
ADJUSTMENT

FUEL RETURN
LINE ORIFICE

62.5 1-1/4 1/4

IDLE SPEED
(OUT OF WATER)

1 1/4

RPM

mm
(in)

KPa
(PSI)

2400

0.5
(.020)

150 - 200
(22 - 29)

1400

3000

0.5
(.020)
PTO SIDE

150 - 200
(22 - 29)

IDLE SPEED
(IN WATER)

67.5

LOW SPEED
SCREW
ADJUSTMENT

PILOT JET

2532201-Book Page 37 Thursday, August 1, 1996 8:17 AM

RPM

1400

67.5

1 1/4

1400

2400

0.5
(.020)

150 - 200
(22 - 29)

60

1-1/4 1/4

1500

3300

0.5
(.020)
PTO SIDE

150 - 200
(22 - 29)

67.5

1 1/4

1400

2500

0.5
(.020)

150 - 200
(22 - 29)

1400

2800

0.5
(.020)
PTO SIDE

150 - 200
(22 - 29)

62.5 1-1/4 1/4

37

CARBURETOR
QUANTITY

MINIMUM
FUEL OCTANE

MAIN JET

SP
(5805)

MIKUNI
BN-38
(DIAPHRAGM)

REGULAR
UNLEADED

87

125

XP
(5851)

MIKUNI
BN-38
(DIAPHRAGM)

REGULAR
UNLEADED

87

107.5

GTS
(5812)

MIKUNI
BN-38
(DIAPHRAGM)

REGULAR
UNLEADED

87

125

GTX
(5860)

MIKUNI
BN-38
(DIAPHRAGM)

REGULAR
UNLEADED

87

107.5

FUEL TYPE

CARBURETOR
TYPE

2532201-Book Page 38 Thursday, August 1, 1996 8:17 AM

1992

38

1 1/4

62.5 1-1/4 1/4

mm
(in)

KPa
(PSI)

2400

0.5
(.020)

150 - 200
(22 - 29)

1400

3000

0.5
(.020)
PTO SIDE

150 - 200
(22 - 29)

1400

2500

0.5
(.020)

150 - 200
(22 - 29)

1400

2800

0.5
(.020)
PTO SIDE

150 - 200
(22 - 29)

HIGH SPEED
SCREW
ADJUSTMENT

POP OFF
PRESSURE

67.5

FUEL RETURN
LINE ORIFICE

62.5 1-1/4 1/4

IDLE SPEED
(OUT OF WATER)

1 1/4

RPM

IDLE SPEED
(IN WATER)

67.5

LOW SPEED
SCREW
ADJUSTMENT

PILOT JET

2532201-Book Page 39 Thursday, August 1, 1996 8:17 AM

RPM

1400

39

CARBURETOR
QUANTITY

MINIMUM
FUEL OCTANE

MAIN JET

SP
(5804)

MIKUNI
BN-38
(DIAPHRAGM)

REGULAR
UNLEADED

87

127.5

XP
(5850)

MIKUNI
BN-38
(DIAPHRAGM)

REGULAR
UNLEADED

87

107.5

GT
(5811)

MIKUNI
BN-38
(DIAPHRAGM)

REGULAR
UNLEADED

87

107.5

FUEL TYPE

CARBURETOR
TYPE

2532201-Book Page 40 Thursday, August 1, 1996 8:17 AM

1991

40

FUEL RETURN
LINE ORIFICE

POP OFF
PRESSURE

RPM

IDLE SPEED
(OUT OF WATER)

IDLE SPEED
(IN WATER)

HIGH SPEED
SCREW
ADJUSTMENT

LOW SPEED
SCREW
ADJUSTMENT

PILOT JET

2532201-Book Page 41 Thursday, August 1, 1996 8:17 AM

RPM

mm
(in)

KPa
(PSI)

0.5
(.020)

150 - 170
(22 - 25)

75

1-1/2

1/4

1400

2900

65

1-1/4

1/4

1400

2900

3 (.118) MAG 150 - 170

0.5 (.020) PTO (22 - 25)

65

1-1/8

1/4

1400

2900

3 (.118) MAG 150 - 170

0.5 (.020) PTO (22 - 25)

41

CARBURETOR
QUANTITY

MINIMUM
FUEL OCTANE

MAIN JET

SP
(5803)

MIKUNI
BN-38
(DIAPHRAGM)

REGULAR
UNLEADED

87

100

GT
(5810)

MIKUNI
BN-38
(DIAPHRAGM)

REGULAR
UNLEADED

87

110

FUEL TYPE

CARBURETOR
TYPE

2532201-Book Page 42 Thursday, August 1, 1996 8:17 AM

1990

42

FUEL RETURN
LINE ORIFICE

POP OFF
PRESSURE

RPM

IDLE SPEED
(OUT OF WATER)

IDLE SPEED
(IN WATER)

HIGH SPEED
SCREW
ADJUSTMENT

LOW SPEED
SCREW
ADJUSTMENT

PILOT JET

2532201-Book Page 43 Thursday, August 1, 1996 8:17 AM

RPM

mm
(in)

KPa
(PSI)

0.8
(.031)

79 - 86
(11.5 12.5)

N.A.

1-1/2 - 2

N.A.

1200

1500

N.A.

1-1/2

N.A.

1200

1500 0.8 (.031) MAG

3 (.118) PTO

79 - 86
(11.5 12.5)

43

MAIN JET

MINIMUM
FUEL OCTANE

CARBURETOR
QUANTITY

MIKUNI
BN-38
(DIAPHRAGM)

FUEL TYPE

CARBURETOR
TYPE

2532201-Book Page 44 Thursday, August 1, 1996 8:17 AM

87

85

1989
SP
(5802)

44

REGULAR
UNLEADED

N.A.
1-1/2 - 2
N.A.
1500

POP OFF
PRESSURE

1200

FUEL RETURN
LINE ORIFICE

RPM

IDLE SPEED
(OUT OF WATER)

IDLE SPEED
(IN WATER)

HIGH SPEED
SCREW
ADJUSTMENT

LOW SPEED
SCREW
ADJUSTMENT

PILOT JET

2532201-Book Page 45 Thursday, August 1, 1996 8:17 AM

RPM
mm
(in)
KPa
(PSI)

0.8
(.031)
79 - 86
(11.5 12.5)

45

MAIN JET

MINIMUM
FUEL OCTANE

CARBURETOR
QUANTITY

MIKUNI
BN-38
(DIAPHRAGM)

FUEL TYPE

CARBURETOR
TYPE

2532201-Book Page 46 Thursday, August 1, 1996 8:17 AM

87

85

1988
SP
(5801)

46

REGULAR
UNLEADED

N.A.
1-1/2 - 2
N.A.
1500

POP OFF
PRESSURE

1200

FUEL RETURN
LINE ORIFICE

RPM

IDLE SPEED
(OUT OF WATER)

IDLE SPEED
(IN WATER)

HIGH SPEED
SCREW
ADJUSTMENT

LOW SPEED
SCREW
ADJUSTMENT

PILOT JET

2532201-Book Page 47 Thursday, August 1, 1996 8:17 AM

RPM
mm
(in)
KPa
(PSI)

0.8
(.031)
79 - 86
(11.5 12.5)

47

2532201-Book Page 48 Thursday, August 1, 1996 8:17 AM

MAIN JET AND PILOT JET

MAIN JET
1988 - 1990

1991 - 1994

1995

SIZE

PART
NUMBER

SIZE

PART
NUMBER

SIZE

PART
NUMBER

70

270 500 006

102.5

270 500 157

132.5

270 500 225

75

270 500 005

105

270 500 158

135

270 500 174

80

270 500 004

107.5

270 500 116

137.5

270 500 268

85

270 500 000

110

270 500 159

140

270 500 251

90

270 500 003

120

270 500 160

142.5

270 500 209

95

270 500 002

122.5

270 500 161

147.5

270 500 210

100

270 500 001

125

270 500 162

110

270 500 081

127.5

270 500 148

120

270 500 153

130

270 500 163

135

270 500 174

1996
SIZE

PART
NUMBER

130

270 500 163

142.5

270 500 209

147.5

270 500 210

PILOT JET
1991 - 1996
SIZE

PART
NUMBER

SIZE

PART
NUMBER

SIZE

PART
NUMBER

55

270 500 202

65

270 500 117

75

270 500 149

57.5

270 500 201

67.5

270 500 165

77.5

270 500 167

60

270 500 180

70

270 500 175

62.5

270 500 164

72.5

270 500 166

48

2532201-Book Page 49 Thursday, August 1, 1996 8:17 AM

SECTION CONTENTS

ELECTRICAL SYSTEM

TABLE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

PAGE
50

Magneto Output
Ignition Type
Spark Plug Number
Spark Plug Gap
Ignition Timing (BTDC)
Generating Coil
Battery Charging Coil
Trigger Coil
Ignition Coil (Primary)
Ignition Coil (Secondary)
Engine Rev Limiter Setting
Battery
Fuse (Starting / Charging / VTS / Holder Relay)
SPARK PLUGS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

68

ABBREVIATIONS:
a

At 6000 RPM.

Engine cold, at 6000 RPM.

All resistance measurements must be performed at room temperature,

at approximately 20C (68F).

Watercraft with engine serial numbers from 3.808.601 to 3.810.887,

the ignition timing is 2.79 mm (.110 in) BTDC.

Low Speed: 120 180.

High Speed: 2.8 4.2.

At 3500 RPM.

CDI: Capacitor Discharge Ignition

DC-CDI: Direct Current Capacitor Discharge Ignition
BTDC: Before Top Dead Center
N.A.= Not Applicable

49

IGNITION
TIMING
(BTDC)

Watt
a

SPARK PLUG
GAP

SPARK
PLUG
NUMBER

IGNITION
TYPE

MAGNETO
OUTPUT

2532201-Book Page 50 Thursday, August 1, 1996 8:17 AM

mm
(in)

Degrees
mm (in)
b

1996
SP
(5876)

160 W
(6000)

CDI

NGK
BR7ES

0.5
(.020)

20
2.41 (.095)

SPX
(5877)

160 W
(6000)

CDI

NGK
BR8ES

0.5
(.020)

20
2.59 (.102)

SPI
(5878)

160 W
(6000)

CDI

NGK
BR7ES

0.5
(.020)

20
2.41 (.095)

XP
(5858-5859)

180 W
(6000)

DC-CDI

NGK
BR8ES

0.5
(.020)

22 f
3.38 (.133)

GSX
(5620)

180 W
(6000)

DC-CDI

NGK
BR8ES

0.5
(.020)

22 f
3.38 (.133)

GTS
(5817)

160 W
(6000)

CDI

NGK
BR7ES

0.5
(.020)

20
2.41 (.095)

GTI
(5865-58665867)

160 W
(6000)

CDI

NGK
BR8ES

0.5
(.020)

20
2.59 (.102)

GTX
(5640)

180 W
(6000)

DC-CDI

NGK
BR8ES

0.5
(.020)

22 f
3.38 (.133)

HX
(5881)

160 W
(6000)

CDI

NGK
BR8ES

0.5
(.020)

20
2.59 (.102)

50

FUSE

ohm K ohm
RPM
c
c

BATTERY

ohm

ENGINE REV
LIMITER
SETTING

TRIGGER COIL

ohm

IGNITION COIL
(SECONDARY)

BATTERY
CHARGING
COIL

ohm

IGNITION COIL
(PRIMARY)

GENERATING
COIL

2532201-Book Page 51 Thursday, August 1, 1996 8:17 AM

V (A)

Starting /
Charging /
VTS
Holder Relay

40 - 76 0.05 - 0.6 N.A. 0.34 - 9 - 15

0.62

6550 12 (19)
50

5 / 15 /
N.A.
N.A.

40 - 76 0.21 - 0.31 N.A. 0.23 - 3.85 0.43 7.15

7000 12 (19)
50

5 / 15 /
7.5
N.A.

40 - 76 0.05 - 0.6 N.A. 0.34 - 9 - 15

0.62

6550 12 (19)
50

5 / 15 /
N.A.
N.A.

N.A.

0.1 - 1.0 190 - 0.33 - 8.4 300 0.62 15.6

7200 12 (19)
50

5 / 2 x15 /
7.5
5

N.A.

0.1 - 1.0 190 - 0.33 - 8.4 300 0.62 15.6

7200 12 (19)
50

5 / 2 x15 /
7.5
5

40 - 76 0.05 - 0.6 N.A. 0.34 - 9 - 15

0.62

6550 12 (19)
50

5 / 15 /
N.A.
N.A.

40 - 76 0.21 - 0.31 N.A. 0.23 - 3.85 0.43 7.15

7000 12 (19)
50

5 / 15 /
N.A.
N.A.

7200 12 (19)
50

5 / 2 x15 /
N.A.
5

7000 12 (19)
50

5 / 15 /
N.A.
N.A.

N.A.

0.1 - 1.0 190 - 0.33 - 8.4 300 0.62 15.6

40 - 76 0.21 - 0.31 N.A. 0.23 - 3.85 0.43 7.15

51

IGNITION
TIMING
(BTDC)

Watt
a

SPARK PLUG
GAP

SPARK
PLUG
NUMBER

IGNITION
TYPE

MAGNETO
OUTPUT

2532201-Book Page 52 Thursday, August 1, 1996 8:17 AM

mm
(in)

Degrees
mm (in)
b

1995
SP
(5873)

160 W
(6000)

CDI

NGK
BR7ES

0.5
(.020)

20
2.41 (.095)

SPX
(5874)

160 W
(6000)

CDI

NGK
BR8ES

0.5
(.020)

20
2.59 (.102)

SPI
(5875)

160 W
(6000)

CDI

NGK
BR7ES

0.5
(.020)

20
2.41 (.095)

XP 800
(5856)

180 W
(6000)

DC-CDI

NGK
BR8ES

0.5
(.020)

22 f
3.38 (.133)

XP
(5857)

160 W
(6000)

CDI

NGK
BR8ES

0.5
(.020)

20
2.59 (.102)

GTS
(5815-5816)

160 W
(6000)

CDI

NGK
BR7ES

0.5
(.020)

20
2.41 (.095)

GTX
(5863-5864)

160 W
(6000)

CDI

NGK
BR8ES

0.5
(.020)

20
2.59 (.102)

HX
(5880)

160 W
(6000)

CDI

NGK
BR8ES

0.5
(.020)

20
2.59 (.102)

52

GENERATING
COIL

BATTERY
CHARGING
COIL

IGNITION COIL
(PRIMARY)

IGNITION COIL
(SECONDARY)

ENGINE REV
LIMITER
SETTING

BATTERY

FUSE

2532201-Book Page 53 Thursday, August 1, 1996 8:17 AM

ohm

ohm

ohm
c

K ohm
c

RPM

V (A)

Starting /
Charging /
VTS

40 - 76 0.05 - 0.6

N.A.

9 - 15

6550
50

12 (19)

5 / 15 /
N.A.

40 - 76 0.05 - 0.6

N.A.

9 - 15

7000
50

12 (19)

5 / 15 /
15

40 - 76 0.05 - 0.6

N.A.

9 - 15

6550
50

12 (19)

5 / 15 /
N.A.

0.34 0.62

9 - 15

7200
50

12 (19)

5 / 15 /
7.5

40 - 76 0.05 - 0.6

N.A.

9 - 15

7000
50

12 (19)

5 / 15 /
7.5

40 - 76 0.05 - 0.6

N.A.

9 - 15

6550
50

12 (19)

5 / 15 /
N.A.

40 - 76 0.05 - 0.6

N.A.

9 - 15

7000
50

12 (19)

5 / 15 /
N.A.

40 - 76 0.05 - 0.6

N.A.

9 - 15

7000
50

12 (19)

5 / 15 /
N.A.

N.A.

0.1 - 1.0

53

IGNITION
TIMING
(BTDC)

Watt
a

SPARK PLUG
GAP

SPARK
PLUG
NUMBER

IGNITION
TYPE

MAGNETO
OUTPUT

2532201-Book Page 54 Thursday, August 1, 1996 8:17 AM

mm
(in)

Degrees
mm (in)
b

1994

54

SP
(5870)

160 W
(6000)

CDI

NGK
BR7ES

0.5
(.020)

21
2.65 (.104)

SPX
(5871)

160 W
(6000)

CDI

NGK
BR8ES

0.5
(.020)

21
2.85 (.112)

SPI
(5872)

160 W
(6000)

CDI

NGK
BR7ES

0.5
(.020)

21
2.65 (.104)

XP
(5854)

160 W
(6000)

CDI

NGK
BR8ES

0.5
(.020)

20
2.59 (.102)

XP
(5855)

160 W
(6000)

CDI

NGK
BR8ES

0.5
(.020)

21
2.85 (.112)

GTS
(5814)

160 W
(6000)

CDI

NGK
BR7ES

0.5
(.020)

21
2.65 (.104)

GTX
(5862)

160 W
(6000)

CDI

NGK
BR8ES

0.5
(.020)

21
2.85 (.112)

GENERATING
COIL

BATTERY
CHARGING
COIL

IGNITION COIL
(PRIMARY)

IGNITION COIL
(SECONDARY)

ENGINE REV
LIMITER
SETTING

BATTERY

FUSE

2532201-Book Page 55 Thursday, August 1, 1996 8:17 AM

ohm

ohm

ohm
c

K ohm
c

RPM

V (A)

Starting /
Charging /
VTS

40 - 76 0.05 - 0.6

N.A.

9 - 15

40 - 76 0.05 - 0.6

N.A.

9 - 15

40 - 76 0.05 - 0.6

N.A.

9 - 15

0.21 - 0.31 0.23 0.43

6550
100

12 (19)

5 / 15 /
N.A.

7000
12 (19)
+ 100, - 50

5 / 15 /
N.A.

12 (19)

5 / 15 /
N.A.

3.85 7.15

7000
12 (19)
+ 100, - 50

5 / 15 /
15

7000
12 (19)
+ 100, - 50

5 / 15 /
15

40 - 76 0.05 - 0.6

N.A.

9 - 15

40 - 76 0.05 - 0.6

N.A.

9 - 15

40 - 76 0.05 - 0.6

N.A.

9 - 15

6550
100

6550
100

12 (19)

5 / 15 /
N.A.

7000
12 (19)
+ 100, - 50

5 / 15 /
N.A.

55

IGNITION
TIMING
(BTDC)

Watt
a

SPARK PLUG
GAP

SPARK
PLUG
NUMBER

IGNITION
TYPE

MAGNETO
OUTPUT

2532201-Book Page 56 Thursday, August 1, 1996 8:17 AM

mm
(in)

Degrees
mm (in)
b

1993

56

SP
(5806)

160 W
(6000)

CDI

NGK
BR7ES

0.5
(.020)

21
2.65 (.104)

SPX
(5807)

160 W
(6000)

CDI

NGK
BR7ES

0.5
(.020)

21
2.65 (.104)

SPI
(5808)

160 W
(6000)

CDI

NGK
BR7ES

0.5
(.020)

21
2.65 (.104)

XP
(5852)

160 W
(6000)

CDI

NGK
BR8ES

0.5
(.020)

20
2.59 (.102)

GTS
(5813)

160 W
(6000)

CDI

NGK
BR7ES

0.5
(.020)

21
2.65 (.104)

GTX
(5861)

160 W
(6000)

CDI

NGK
BR7ES

0.5
(.020)

21
2.65 (.104)

GENERATING
COIL

BATTERY
CHARGING
COIL

IGNITION COIL
(PRIMARY)

IGNITION COIL
(SECONDARY)

ENGINE REV
LIMITER
SETTING

BATTERY

FUSE

2532201-Book Page 57 Thursday, August 1, 1996 8:17 AM

ohm

ohm

ohm
c

K ohm
c

RPM

V (A)

Starting /
Charging /
VTS

40 - 76 0.05 - 0.6

N.A.

40 - 76 0.05 - 0.6
40 - 76 0.05 - 0.6
e

9 - 15

6550
100

12 (19)

5 / 15 /
N.A.

N.A.

9 - 15

6550
100

12 (19)

5 / 15 /
N.A.

N.A.

9 - 15

6550
100

12 (19)

5 / 15 /
N.A.

3.85 7.15

7050
50

12 (19)

5 / 15 /
15

0.21 - 0.31 0.23 0.43

40 - 76 0.05 - 0.6

N.A.

9 - 15

6550
100

12 (19)

5 / 15 /
N.A.

40 - 76 0.05 - 0.6

N.A.

9 - 15

6550
100

12 (19)

5 / 15 /
N.A.

57

IGNITION
TIMING
(BTDC)

Watt
a

SPARK PLUG
GAP

SPARK
PLUG
NUMBER

IGNITION
TYPE

MAGNETO
OUTPUT

2532201-Book Page 58 Thursday, August 1, 1996 8:17 AM

mm
(in)

Degrees
mm (in)
b

1992

58

SP
(5805)

160 W
(6000)

CDI

NGK
BR7ES

0.5
(.020)

21
2.65 (.104)

XP
(5851)

160 W
(6000)

CDI

NGK
BR7ES

0.5
(.020)

21
2.65 (.104)

GTS
(5812)

160 W
(6000)

CDI

NGK
BR7ES

0.5
(.020)

21
2.65 (.104)

GTX
(5860)

160 W
(6000)

CDI

NGK
BR7ES

0.5
(.020)

21
2.65 (.104)

GENERATING
COIL

BATTERY
CHARGING
COIL

IGNITION COIL
(PRIMARY)

IGNITION COIL
(SECONDARY)

ENGINE REV
LIMITER
SETTING

BATTERY

FUSE

2532201-Book Page 59 Thursday, August 1, 1996 8:17 AM

ohm

ohm

ohm
c

K ohm
c

RPM

V (A)

Starting /
Charging /
VTS

40 - 76 0.05 - 0.6

N.A.

9 - 15

6550
100

12 (19)

5 / 15 /
N.A.

40 - 76 0.05 - 0.6

N.A.

9 - 15

6550
100

12 (19)

5 / 15 /
N.A.

40 - 76 0.05 - 0.6

N.A.

9 - 15

6550
100

12 (19)

5 / 15 /
N.A.

40 - 76 0.05 - 0.6

N.A.

9 - 15

6550
100

12 (19)

5 / 15 /
N.A.

59

IGNITION
TIMING
(BTDC)

Watt
a

SPARK PLUG
GAP

SPARK
PLUG
NUMBER

IGNITION
TYPE

MAGNETO
OUTPUT

2532201-Book Page 60 Thursday, August 1, 1996 8:17 AM

mm
(in)

Degrees
mm (in)
b

1991

60

SP
(5804)

160 W
(5500)

CDI

NGK
BR7ES

0.5
(.020)

19
2.18 (.086)

XP
(5850)

160 W
(5500)

CDI

NGK
BR7ES

0.5
(.020)

19
2.18 (.086)

GT
(5811)

160 W
(5500)

CDI

NGK
BR7ES

0.6
(.024)

19
2.18 (.086)

GENERATING
COIL

BATTERY
CHARGING
COIL

IGNITION COIL
(PRIMARY)

IGNITION COIL
(SECONDARY)

ENGINE REV
LIMITER
SETTING

BATTERY

FUSE

2532201-Book Page 61 Thursday, August 1, 1996 8:17 AM

ohm

ohm

ohm
c

K ohm
c

RPM

V (A)

Starting /
Charging /
VTS

0.21 - 0.31 0.23 0.43

5.85 6.50

6500
200

12 (20)

8 / 15 /
N.A.

0.21 - 0.31 0.23 0.43

5.85 6.50

6500
200

12 (20)

8 / 15 /
N.A.

0.21 - 0.31 0.23 0.43

5.85 6.50

6500
200

12 (20)

8 / 15 /
N.A.

61

SPARK PLUG
GAP

IGNITION
TIMING
(BTDC)

Watt
a

SPARK
PLUG
NUMBER

IGNITION
TYPE

MAGNETO
OUTPUT

2532201-Book Page 62 Thursday, August 1, 1996 8:17 AM

mm
(in)

Degrees
mm (in)
b

1990

62

SP
(5803)

160 W
(5500)

CDI

CHAMPION
0.6
RN4C
(.024)

19
2.18 (.086)

GT
(5810)

160 W
(5500)

CDI

CHAMPION
0.6
RN4C
(.024)

19
2.18 (.086)

GENERATING
COIL

BATTERY
CHARGING
COIL

IGNITION COIL
(PRIMARY)

IGNITION COIL
(SECONDARY)

ENGINE REV
LIMITER
SETTING

BATTERY

FUSE

2532201-Book Page 63 Thursday, August 1, 1996 8:17 AM

ohm

ohm

ohm
c

K ohm
c

RPM

V (A)

Starting /
Charging /
VTS

0.21 - 0.31 0.23 0.43

5.85 6.50

6500
200

12 (20)

8 / 15 /
N.A.

0.21 - 0.31 0.23 0.43

5.85 6.50

6500
200

12 (20)

8 / 15 /
N.A.

63

SPARK PLUG
GAP

IGNITION
TIMING
(BTDC)

Watt
a

SPARK
PLUG
NUMBER

IGNITION
TYPE

MAGNETO
OUTPUT

2532201-Book Page 64 Thursday, August 1, 1996 8:17 AM

mm
(in)

Degrees
mm (in)
b

1989
SP
(5802)

64

160 W
(5500)

CDI

CHAMPION
0.5
RN4C
(.020)

19
2.18 (.086)
d

GENERATING
COIL

BATTERY
CHARGING
COIL

IGNITION COIL
(PRIMARY)

IGNITION COIL
(SECONDARY)

ENGINE REV
LIMITER
SETTING

BATTERY

FUSE

2532201-Book Page 65 Thursday, August 1, 1996 8:17 AM

ohm

ohm

ohm
c

K ohm
c

RPM

V (A)

Starting /
Charging /
VTS

0.21 - 0.31 0.23 0.43

2.45 4.55

6300

12 (20) 8 / N.A. /
N.A.

65

SPARK PLUG
GAP

IGNITION
TIMING
(BTDC)

Watt
a

SPARK
PLUG
NUMBER

IGNITION
TYPE

MAGNETO
OUTPUT

2532201-Book Page 66 Thursday, August 1, 1996 8:17 AM

mm
(in)

Degrees
mm (in)
b

1988
SP
(5801)

66

160 W
(5500)

CDI

CHAMPION
0.7
RN4C
(.028)

19
2.18 (.086)
d

GENERATING
COIL

BATTERY
CHARGING
COIL

IGNITION COIL
(PRIMARY)

IGNITION COIL
(SECONDARY)

ENGINE REV
LIMITER
SETTING

BATTERY

FUSE

2532201-Book Page 67 Thursday, August 1, 1996 8:17 AM

ohm

ohm

ohm
c

K ohm
c

RPM

V (A)

Starting /
Charging /
VTS

0.21 - 0.31 0.23 0.43

2.45 4.55

6800

12 (20) 8 / N.A. /
N.A.

67

2532201-Book Page 68 Thursday, August 1, 1996 8:17 AM

SPARK PLUGS

68

NGK SPARK PLUG

PART NUMBER

BR7ES

278 000 140

BR8ES

278 000 609

2532201-Book Page 69 Thursday, August 1, 1996 8:17 AM

SECTION CONTENTS

PROPULSION SYSTEM

TABLE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

PAGE
70

Propulsion System
Jet Pump Type
Impeller Rotation (Seen From Rear)
Transmission
Coupling Type
Oil Type
Minimum Required Water Level
Drive Shaft Deflection (Maximum)
Impeller Outside Diameter
Impeller / Wear Ring Clearance
Impeller Shaft End Play
Impeller Shaft Side Play
Impeller Pitch / Material
ABBREVIATIONS:
a

SEA-DOO JET PUMP SYNTHETIC POLYOLESTER OIL SAE 75W90 GL5.

Do not mix different brands or oil types.

N.A.: Not Applicable

69

COUPLING TYPE

Direct
Drive

Crown
Splines

SPX
(5877)

CounterBombardier Axial
Flow clockwise
Formula
Single
Pump
Stage

Direct
Drive

Crown
Splines

SPI
(5878)

CounterBombardier Axial
Flow clockwise
Formula
Single
Pump
Stage

Direct
Drive

Crown
Splines

CounterXP
Bombardier Axial
Flow clockwise
(5858-5859)
Formula
Single
Pump
Stage

Direct
Drive

Crown
Splines

GSX
(5620)

CounterBombardier Axial
Flow clockwise
Formula
Single
Pump
Stage

Direct
Drive

Crown
Splines

GTS
(5817)

CounterBombardier Axial
Flow clockwise
Formula
Single
Pump
Stage

Direct
Drive

Crown
Splines

CounterBombardier Axial
GTI
Flow clockwise
Formula
(5865-5866Single
Pump
5867)
Stage

Direct
Drive

Crown
Splines

CounterBombardier Axial
Flow clockwise
Formula
Single
Pump
Stage

Direct
Drive

Crown
Splines

IMPELLER
ROTATION
(SEEN
FROM REAR)

CounterBombardier Axial
Flow clockwise
Formula
Single
Pump
Stage

JET PUMP TYPE

SP
(5876)

PROPULSION
SYSTEM

TRANSMISSION

2532201-Book Page 70 Thursday, August 1, 1996 8:17 AM

1996

GTX
(5640)

70

mm
(in)

N /U
mm
(in)

mm
(in)

mm
(in)

IMPELLER
PITCH / MATERIAL

IMPELLER SHAFT
SIDE PLAY

mm
(in)

IMPELLER
SHAFT END
PLAY

cm
(in)

IMPELLER / WEAR
RING CLEARANCE

OIL TYPE
MINIMUM
REQUIRED
WATER LEVEL
DRIVE SHAFT
DEFLECTION
(MAXIMUM)
IMPELLER
OUTSIDE
DIAMETER

2532201-Book Page 71 Thursday, August 1, 1996 8:17 AM

90
(35)

18.8
0.5 139.5 0.31 .13 0.12 - 0.54 0.05
(.020) (5.490) (.012 .005) (.005 - .021) (.002) Aluminum
1.02
(.040)

90
(35)

0.5 139.5 0.31 .13 0.12 - 0.54 0.05 11 - 24

(.020) (5.490) (.012 .005) (.005 - .021) (.002) Stainless
Steel
1.02
(.040)

90
(35)

0.5 139.5 0.31 .13 0.12 - 0.54 0.05 11 - 26

(.020) (5.490) (.012 .005) (.005 - .021) (.002) Stainless
Steel
1.02
(.040)

90
(35)

0.5 139.5 0.31 .13 0.12 - 0.54 0.05 17 - 25

(.020) (5.490) (.012 .005) (.005 - .021) (.002) Stainless
Steel
1.02
(.040)

90
(35)

0.5 139.5 0.31 .13 0.12 - 0.54 0.05 17 - 25

(.020) (5.490) (.012 .005) (.005 - .021) (.002) Stainless
Steel
1.02
(.040)

90
(35)

0.5 139.5 0.31 .13 0.12 - 0.54 0.05 10 - 25

(.020) (5.490) (.012 .005) (.005 - .021) (.002) Stainless
Steel
1.02
(.040)

90
(35)

0.5 139.5 0.31 .13 0.12 - 0.54 0.05 11 - 24

(.020) (5.490) (.012 .005) (.005 - .021) (.002) Stainless
Steel
1.02
(.040)

90
(35)

0.5 139.5 0.31 .13 0.12 - 0.54 0.05 17 - 25

(.020) (5.490) (.012 .005) (.005 - .021) (.002) Stainless
Steel
1.02
(.040)

71

HX
(5881)

72

Counter- Direct
Bombardier Axial
Flow clockwise Drive /
Formula
Split
Single
Pump
FR &RR
Stage

COUPLING TYPE

TRANSMISSION

IMPELLER
ROTATION
(SEEN
FROM REAR)

JET PUMP TYPE

PROPULSION
SYSTEM

2532201-Book Page 72 Thursday, August 1, 1996 8:17 AM

Driving
Claw /
Rubber
Cushion

90
(35)

mm
(in)

N /U
mm
(in)

mm
(in)

mm
(in)

IMPELLER
PITCH / MATERIAL

IMPELLER SHAFT
SIDE PLAY

mm
(in)

IMPELLER
SHAFT END
PLAY

cm
(in)

IMPELLER / WEAR
RING CLEARANCE

OIL TYPE
MINIMUM
REQUIRED
WATER LEVEL
DRIVE SHAFT
DEFLECTION
(MAXIMUM)
IMPELLER
OUTSIDE
DIAMETER

2532201-Book Page 73 Thursday, August 1, 1996 8:17 AM

0.5 139.5 0.31 .13 0.12 - 0.54 0.05 11 - 24

(.020) (5.490) (.012 .005) (.005 - .021) (.002) Stainless
Steel
1.02
(.040)

73

COUPLING TYPE

Direct
Drive

Crown
Splines

SPX
(5874)

CounterBombardier Axial
Flow clockwise
Formula
Single
Pump
Stage

Direct
Drive

Crown
Splines

SPI
(5875)

CounterBombardier Axial
Flow clockwise
Formula
Single
Pump
Stage

Direct
Drive

Crown
Splines

XP
800
(5856)

CounterBombardier Axial
Flow clockwise
Formula
Single
Pump
Stage

Direct
Drive

Crown
Splines

XP
(5857)

CounterBombardier Axial
Flow clockwise
Formula
Single
Pump
Stage

Direct
Drive

Crown
Splines

CounterGTS
Bombardier Axial
Flow clockwise
(5815-5816)
Formula
Single
Pump
Stage

Direct
Drive

Crown
Splines

CounterGTX
Bombardier Axial
Flow clockwise
(5863-5864)
Formula
Single
Pump
Stage

Direct
Drive

Crown
Splines

IMPELLER
ROTATION
(SEEN
FROM REAR)

CounterBombardier Axial
Flow clockwise
Formula
Single
Pump
Stage

JET PUMP TYPE

SP
(5873)

PROPULSION
SYSTEM

TRANSMISSION

2532201-Book Page 74 Thursday, August 1, 1996 8:17 AM

1995

HX
(5880)

74

Crown
Counter- Direct
Bombardier Axial
Flow clockwise Drive / Splines /
Formula
Rubber
Split
Single
Pump
FR &RR Coupling
Stage

mm
(in)

N /U
mm
(in)

mm
(in)

mm
(in)

IMPELLER
PITCH / MATERIAL

IMPELLER SHAFT
SIDE PLAY

mm
(in)

IMPELLER
SHAFT END
PLAY

cm
(in)

IMPELLER / WEAR
RING CLEARANCE

OIL TYPE
MINIMUM
REQUIRED
WATER LEVEL
DRIVE SHAFT
DEFLECTION
(MAXIMUM)
IMPELLER
OUTSIDE
DIAMETER

2532201-Book Page 75 Thursday, August 1, 1996 8:17 AM

90
(35)

18.8
0.5 139.5 0.31 .13 0.12 - 0.54 0.05
(.020) (5.490) (.012 .005) (.005 - .021) (.002) Aluminum
1.02
(.040)

90
(35)

0.5 139.5 0.31 .13 0.12 - 0.54 0.05 11 - 23

(.020) (5.490) (.012 .005) (.005 - .021) (.002) Stainless
Steel
1.02
(.040)

90
(35)

0.5 139.5 0.31 .13 0.12 - 0.54 0.05 11 - 26

(.020) (5.490) (.012 .005) (.005 - .021) (.002) Stainless
Steel
1.02
(.040)

90
(35)

0.5 139.5 0.31 .13 0.12 - 0.54 0.05 17 - 25

(.020) (5.490) (.012 .005) (.005 - .021) (.002) Stainless
Steel
1.02
(.040)

90
(35)

0.5 139.5 0.31 .13 0.12 - 0.54 0.05 11 - 24

(.020) (5.490) (.012 .005) (.005 - .021) (.002) Stainless
Steel
1.02
(.040)

90
(35)

0.5 139.5 0.31 .13 0.12 - 0.54 0.05 10 - 25

(.020) (5.490) (.012 .005) (.005 - .021) (.002) Stainless
Steel
1.02
(.040)

90
(35)

0.5 139.5 0.31 .13 0.12 - 0.54 0.05 11 - 24

(.020) (5.490) (.012 .005) (.005 - .021) (.002) Stainless
Steel
1.02
(.040)

90
(35)

0.5 139.5 0.31 .13 0.12 - 0.54 0.05 11 - 24

(.020) (5.490) (.012 .005) (.005 - .021) (.002) Stainless
Steel
1.02
(.040)

75

COUPLING TYPE

Direct
Drive

Crown
Splines

SPX
(5871)

CounterBombardier Axial
Flow clockwise
Formula
Single
Pump
Stage

Direct
Drive

Crown
Splines

SPI
(5872)

CounterBombardier Axial
Flow clockwise
Formula
Single
Pump
Stage

Direct
Drive

Crown
Splines

XP
(5854)

CounterBombardier Axial
Flow clockwise
Formula
Single
Pump
Stage

Direct
Drive

Crown
Splines

XP
(5855)

CounterBombardier Axial
Flow clockwise
Formula
Single
Pump
Stage

Direct
Drive

Crown
Splines

GTS
(5814)

CounterBombardier Axial
Flow clockwise
Formula
Single
Pump
Stage

Direct
Drive

Crown
Splines

GTX
(5862)

CounterBombardier Axial
Flow clockwise
Formula
Single
Pump
Stage

Direct
Drive

Crown
Splines

IMPELLER
ROTATION
(SEEN
FROM REAR)

CounterBombardier Axial
Flow clockwise
Formula
Single
Pump
Stage

JET PUMP TYPE

SP
(5870)

PROPULSION
SYSTEM

TRANSMISSION

2532201-Book Page 76 Thursday, August 1, 1996 8:17 AM

1994

76

mm
(in)

N /U
mm
(in)

mm
(in)

mm
(in)

IMPELLER
PITCH / MATERIAL

IMPELLER SHAFT
SIDE PLAY

mm
(in)

IMPELLER
SHAFT END
PLAY

cm
(in)

IMPELLER / WEAR
RING CLEARANCE

OIL TYPE
MINIMUM
REQUIRED
WATER LEVEL
DRIVE SHAFT
DEFLECTION
(MAXIMUM)
IMPELLER
OUTSIDE
DIAMETER

2532201-Book Page 77 Thursday, August 1, 1996 8:17 AM

90
(35)

18.8
0.5 139.5 0.31 .13 0.12 - 0.54 0.05
(.020) (5.490) (.012 .005) (.005 - .021) (.002) Aluminum
1.02
(.040)

90
(35)

0.5 139.5 0.31 .13 0.12 - 0.54 0.05 11 - 26

(.020) (5.490) (.012 .005) (.005 - .021) (.002) Stainless
Steel
1.02
(.040)

90
(35)

0.5 139.5 0.31 .13 0.12 - 0.54 0.05 14 - 21

(.020) (5.490) (.012 .005) (.005 - .021) (.002) Stainless
Steel
1.02
(.040)

90
(35)

0.5 139.5 0.31 .13 0.12 - 0.54 0.05 11 - 23

(.020) (5.490) (.012 .005) (.005 - .021) (.002) Stainless
Steel
1.02
(.040)

90
(35)

0.5 139.5 0.31 .13 0.12 - 0.54 0.05 11 - 26

(.020) (5.490) (.012 .005) (.005 - .021) (.002) Stainless
Steel
1.02
(.040)

90
(35)

0.5 139.5 0.31 .13 0.12 - 0.54 0.05 14 - 20

(.020) (5.490) (.012 .005) (.005 - .021) (.002) Stainless
Steel
1.02
(.040)

90
(35)

0.5 139.5 0.31 .13 0.12 - 0.54 0.05 15 - 23

(.020) (5.490) (.012 .005) (.005 - .021) (.002) Stainless
Steel
1.02
(.040)

77

COUPLING TYPE

Direct
Drive

Crown
Splines

SPX
(5807)

CounterBombardier Axial
Flow clockwise
Formula
Single
Pump
Stage

Direct
Drive

Crown
Splines

SPI
(5808)

CounterBombardier Axial
Flow clockwise
Formula
Single
Pump
Stage

Direct
Drive

Crown
Splines

XP
(5852)

CounterBombardier Axial
Flow clockwise
Formula
Single
Pump
Stage

Direct
Drive

Crown
Splines

GTS
(5813)

CounterBombardier Axial
Flow clockwise
Formula
Single
Pump
Stage

Direct
Drive

Crown
Splines

GTX
(5861)

CounterBombardier Axial
Flow clockwise
Formula
Single
Pump
Stage

Direct
Drive

Crown
Splines

IMPELLER
ROTATION
(SEEN
FROM REAR)

CounterBombardier Axial
Flow clockwise
Formula
Single
Pump
Stage

JET PUMP TYPE

SP
(5806)

PROPULSION
SYSTEM

TRANSMISSION

2532201-Book Page 78 Thursday, August 1, 1996 8:17 AM

1993

78

mm
(in)

N /U
mm
(in)

mm
(in)

mm
(in)

IMPELLER
PITCH / MATERIAL

IMPELLER SHAFT
SIDE PLAY

mm
(in)

IMPELLER
SHAFT END
PLAY

cm
(in)

IMPELLER / WEAR
RING CLEARANCE

OIL TYPE
MINIMUM
REQUIRED
WATER LEVEL
DRIVE SHAFT
DEFLECTION
(MAXIMUM)
IMPELLER
OUTSIDE
DIAMETER

2532201-Book Page 79 Thursday, August 1, 1996 8:17 AM

60
(24)

18.8
0.5 139.5 0.31 .13 0.12 - 0.54 0.05
(.020) (5.490) (.012 .005) (.005 - .021) (.002) Aluminum
1.02
(.040)

60
(24)

0.5 139.5 0.31 .13 0.12 - 0.54 0.05 14 - 21

(.020) (5.490) (.012 .005) (.005 - .021) (.002) Stainless
Steel
1.02
(.040)

60
(24)

17.7
0.5 139.5 0.31 .13 0.12 - 0.54 0.05
(.020) (5.490) (.012 .005) (.005 - .021) (.002) Stainless
Steel
1.02
(.040)

90
(35)

0.5 139.5 0.31 .13 0.12 - 0.54 0.05 11 - 26

(.020) (5.490) (.012 .005) (.005 - .021) (.002) Stainless
Steel
1.02
(.040)

90
(35)

17
0.5 139.5 0.31 .13 0.12 - 0.54 0.05
(.020) (5.490) (.012 .005) (.005 - .021) (.002) Stainless
Steel
1.02
(.040)

90
(35)

18.3
0.5 139.5 0.31 .13 0.12 - 0.54 0.05
(.020) (5.490) (.012 .005) (.005 - .021) (.002) Stainless
Steel
1.02
(.040)

79

COUPLING TYPE

Direct
Drive

Crown
Splines

XP
(5851)

CounterBombardier Axial
Flow clockwise
Formula
Single
Pump
Stage

Direct
Drive

Crown
Splines

GTS
(5812)

CounterBombardier Axial
Flow clockwise
Formula
Single
Pump
Stage

Direct
Drive

Crown
Splines

GTX
(5860)

CounterBombardier Axial
Flow clockwise
Formula
Single
Pump
Stage

Direct
Drive

Crown
Splines

IMPELLER
ROTATION
(SEEN
FROM REAR)

CounterBombardier Axial
Flow clockwise
Formula
Single
Pump
Stage

JET PUMP TYPE

SP
(5805)

PROPULSION
SYSTEM

TRANSMISSION

2532201-Book Page 80 Thursday, August 1, 1996 8:17 AM

1992

80

mm
(in)

N /U
mm
(in)

mm
(in)

mm
(in)

IMPELLER
PITCH / MATERIAL

IMPELLER SHAFT
SIDE PLAY

mm
(in)

IMPELLER
SHAFT END
PLAY

cm
(in)

IMPELLER / WEAR
RING CLEARANCE

OIL TYPE
MINIMUM
REQUIRED
WATER LEVEL
DRIVE SHAFT
DEFLECTION
(MAXIMUM)
IMPELLER
OUTSIDE
DIAMETER

2532201-Book Page 81 Thursday, August 1, 1996 8:17 AM

60
(24)

18.8
0.5 139.5 0.31 .13 0.12 - 0.54 0.05
(.020) (5.490) (.012 .005) (.005 - .021) (.002) Aluminum
1.02
(.040)

60
(24)

0.5 139.5 0.31 .13 0.12 - 0.54 0.05 11 - 26

(.020) (5.490) (.012 .005) (.005 - .021) (.002) Stainless
Steel
1.02
(.040)

90
(35)

17
0.5 139.5 0.31 .13 0.12 - 0.54 0.05
(.020) (5.490) (.012 .005) (.005 - .021) (.002) Aluminum
1.02
(.040)

90
(35)

18.3
0.5 139.5 0.31 .13 0.12 - 0.54 0.05
(.020) (5.490) (.012 .005) (.005 - .021) (.002) Stainless
Steel
1.02
(.040)

81

COUPLING TYPE

Direct
Drive

Crown
Splines

XP
(5850)

CounterBombardier Axial
Flow clockwise
Formula
Single
Pump
Stage

Direct
Drive

Crown
Splines

GT
(5811)

CounterBombardier Axial
Flow clockwise
Formula
Single
Pump
Stage

Direct
Drive

Crown
Splines

IMPELLER
ROTATION
(SEEN
FROM REAR)

CounterBombardier Axial
Flow clockwise
Formula
Single
Pump
Stage

JET PUMP TYPE

SP
(5804)

PROPULSION
SYSTEM

TRANSMISSION

2532201-Book Page 82 Thursday, August 1, 1996 8:17 AM

1991

82

mm
(in)

N /U
mm
(in)

mm
(in)

mm
(in)

IMPELLER
PITCH / MATERIAL

IMPELLER SHAFT
SIDE PLAY

mm
(in)

IMPELLER
SHAFT END
PLAY

cm
(in)

IMPELLER / WEAR
RING CLEARANCE

OIL TYPE
MINIMUM
REQUIRED
WATER LEVEL
DRIVE SHAFT
DEFLECTION
(MAXIMUM)
IMPELLER
OUTSIDE
DIAMETER

2532201-Book Page 83 Thursday, August 1, 1996 8:17 AM

60
(24)

18.8
0.5 139.5 0.31 .13 0.12 - 0.54 0.05
(.020) (5.490) (.012 .005) (.005 - .021) (.002) Aluminum
1.02
(.040)

60
(24)

0.5 139.5 0.31 .13 0.12 - 0.54 0.05 11 - 26

(.020) (5.490) (.012 .005) (.005 - .021) (.002) Stainless
Steel
1.02
(.040)

60
(24)

17
0.5 139.5 0.31 .13 0.12 - 0.54 0.05
(.020) (5.490) (.012 .005) (.005 - .021) (.002) Stainless
Steel
1.02
(.040)

83

COUPLING TYPE

Direct
Drive

Crown
Splines

GT
(5810)

CounterBombardier Axial
Flow clockwise
Formula
Single
Pump
Stage

Direct
Drive

Crown
Splines

IMPELLER
ROTATION
(SEEN
FROM REAR)

CounterBombardier Axial
Flow clockwise
Formula
Single
Pump
Stage

JET PUMP TYPE

SP
(5803)

PROPULSION
SYSTEM

TRANSMISSION

2532201-Book Page 84 Thursday, August 1, 1996 8:17 AM

1990

84

mm
(in)

N /U
mm
(in)

mm
(in)

mm
(in)

IMPELLER
PITCH / MATERIAL

IMPELLER SHAFT
SIDE PLAY

mm
(in)

IMPELLER
SHAFT END
PLAY

cm
(in)

IMPELLER / WEAR
RING CLEARANCE

OIL TYPE
MINIMUM
REQUIRED
WATER LEVEL
DRIVE SHAFT
DEFLECTION
(MAXIMUM)
IMPELLER
OUTSIDE
DIAMETER

2532201-Book Page 85 Thursday, August 1, 1996 8:17 AM

60
(24)

18.8
2
139.5 0.31 .13 0.12 - 0.54 0.05
(.078) (5.490) (.012 .005 (.005 - .021) (.002) Aluminum
1.02
(.040)

60
(24)

17
2
139.5 0.31 .13 0.12 - 0.54 0.05
(.078) (5.490) (.012 .005 (.005 - .021) (.002) Stainless
Steel
1.02
(.040)

85

TRANSMISSION

COUPLING TYPE

IMPELLER
ROTATION
(SEEN
FROM REAR)

JET PUMP TYPE

PROPULSION
SYSTEM

2532201-Book Page 86 Thursday, August 1, 1996 8:17 AM

Direct
Drive

Crown
Splines

1989
SP
(5802)

86

CounterBombardier Axial
Flow clockwise
Formula
Single
Pump
Stage

cm
(in)

a
60
(24)
mm
(in)
N /U
mm
(in)
mm
(in)
mm
(in)

N.A.
N.A.

IMPELLER
PITCH / MATERIAL

IMPELLER SHAFT
SIDE PLAY

0.5 139.5 0.31 .13

(.020) (5.490) (.012 .005
1.02
(.040)

IMPELLER
SHAFT END
PLAY

mm
(in)

IMPELLER / WEAR
RING CLEARANCE

OIL TYPE
MINIMUM
REQUIRED
WATER LEVEL
DRIVE SHAFT
DEFLECTION
(MAXIMUM)
IMPELLER
OUTSIDE
DIAMETER

2532201-Book Page 87 Thursday, August 1, 1996 8:17 AM

18.8
Aluminum

87

TRANSMISSION

COUPLING TYPE

IMPELLER
ROTATION
(SEEN
FROM REAR)

JET PUMP TYPE

PROPULSION
SYSTEM

2532201-Book Page 88 Thursday, August 1, 1996 8:17 AM

Direct
Drive

Crown
Splines

1988
SP
(5801)

88

CounterBombardier Axial
Flow clockwise
Formula
Single
Pump
Stage

cm
(in)

a
60
(24)
mm
(in)
N /U
mm
(in)
mm
(in)
mm
(in)

N.A.
N.A.

IMPELLER
PITCH / MATERIAL

IMPELLER SHAFT
SIDE PLAY

0.5 139.5 0.31 .13

(.020) (5.490) (.012 .005)
1.02
(.040)

IMPELLER
SHAFT END
PLAY

mm
(in)

IMPELLER / WEAR
RING CLEARANCE

OIL TYPE
MINIMUM
REQUIRED
WATER LEVEL
DRIVE SHAFT
DEFLECTION
(MAXIMUM)
IMPELLER
OUTSIDE
DIAMETER

2532201-Book Page 89 Thursday, August 1, 1996 8:17 AM

16.5
Aluminum

89

2532201-Book Page 90 Thursday, August 1, 1996 8:17 AM

90

2532201-Book Page 91 Thursday, August 1, 1996 8:17 AM

SECTION CONTENTS

DIMENSION / CAPACITIES

TABLE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

PAGE
92

Number of Passengers
Overall Length
Overall Width
Overall Height
Dry Weight
Load Limit
Fuel Tank
Oil Injection Reservoir
Impeller Shaft Reservoir
ABBREVIATIONS:
a

Driver Included.

Two passengers if watercraft is equipped with the Touring Seat

Option.

Reserve Included.

91

NUMBER
OF
PASSENGERS

OVERALL
LENGTH

OVERALL
WIDTH

OVERALL
HEIGHT

2532201-Book Page 92 Thursday, August 1, 1996 8:17 AM

cm
(in)

cm
(in)

cm
(in)

1996
SP
(5876)

254
(100)

105
(41.3)

92
(36.2)

SPX
(5877)

254
(100)

105
(41.3)

92
(36.2)

SPI
(5878)

254
(100)

105
(41.3)

92
(36.2)

XP
(5858-5859)

254
(100)

105
(41.3)

92
(36.2)

GSX
(5620)

267
(105)

116
(45.6)

99
(38.9)

GTS
(5817)

3b

302
(119)

119
(46.9)

95
(37.4)

GTI
(5865-58665867)

3b

302
(119)

119
(46.9)

95
(37.4)

GTX
(5640)

3b

312
(122)

119
(46.9)

94
(37.0)

HX
(5881)

273
(107.5)

85
(33.5)

97
(38.2)

92

DRY WEIGHT

LOAD LIMIT

FUEL TANK

OIL INJECTION
RESERVOIR

IMPELLER
SHAFT
RESERVOIR

2532201-Book Page 93 Thursday, August 1, 1996 8:17 AM

kg
(lb)

kg
(lb)

L
(U.S. gal)
c

L
(U.S. gal)

mL
(U.S. oz)

176
(388)

160
(353)

34
(9)

4.5
(1.2)

90
(3.0)

187
(412)

160
(353)

34
(9)

4.5
(1.2)

90
(3.0)

178
(392)

160
(353)

34
(9)

4.5
(1.2)

90
(3.0)

197
(434)

160
(353)

34
(9)

4.5
(1.2)

90
(3.0)

227
(504)

165
(366)

56.5
(14)

6
(1.5)

90
(3.0)

210
(463)

225
(496)

46
(12)

4.5
(1.2)

90
(3.0)

220
(488)

225
(500)

46
(12)

4.5
(1.2)

90
(3.0)

262
(582)

230
(511)

56.5
(14)

6
(1.5)

90
(3.0)

177
(390)

110
(250)

27
(7)

4.0
(1.1)

90
(3.0)

93

NUMBER
OF
PASSENGERS

OVERALL
LENGTH

OVERALL
WIDTH

OVERALL
HEIGHT

2532201-Book Page 94 Thursday, August 1, 1996 8:17 AM

cm
(in)

cm
(in)

cm
(in)

1995
SP
(5873)

254
(100)

105
(41.3)

92
(36.2)

SPX
(5874)

254
(100)

105
(41.3)

92
(36.2)

SPI
(5875)

254
(100)

105
(41.3)

92
(36.2)

XP 800
(5856)

262
(103)

105
(41.3)

92
(36.2)

XP
(5857)

262
(103)

105
(41.3)

92
(36.2)

GTS
(5815-5816)

3b

302
(119)

119
(46.9)

95
(37.4)

GTX
(5863-5864)

3b

302
(119)

119
(46.9)

95
(37.4)

HX
(5880)

273
(107.5)

85
(33.5)

97
(38.2)

94

DRY WEIGHT

LOAD LIMIT

FUEL TANK

OIL INJECTION
RESERVOIR

IMPELLER
SHAFT
RESERVOIR

2532201-Book Page 95 Thursday, August 1, 1996 8:17 AM

kg
(lb)

kg
(lb)

L
(U.S. gal)
c

L
(U.S. gal)

mL
(U.S. oz)

176
(388)

160
(353)

34
(9)

4.5
(1.2)

65
(2.2)

180
(397)

160
(353)

34
(9)

4.5
(1.2)

65
(2.2)

178
(392)

160
(353)

34
(9)

4.5
(1.2)

65
(2.2)

197
(434)

110
(250)

34
(9)

4.5
(1.2)

90
(3.0)

187
(412)

160
(353)

34
9)

4.5
(1.2)

90
(3.0)

210
(463)

225
(496)

45
(12)

4.5
(1.2)

65
(2.2)

220
(485)

225
(496)

45
(12)

4.5
(1.2)

65
(2.2)

177
(390)

110
(250)

27
(7)

4.0
(1.1)

90
(3.0)

95

NUMBER
OF
PASSENGERS

OVERALL
LENGTH

OVERALL
WIDTH

OVERALL
HEIGHT

2532201-Book Page 96 Thursday, August 1, 1996 8:17 AM

cm
(in)

cm
(in)

cm
(in)

1994

96

SP
(5870)

254
(100)

105
(41.3)

92
(36.2)

SPX
(5871)

254
(100)

105
(41.3)

92
(36.2)

SPI
(5872)

254
(100)

105
(41.3)

92
(36.2)

XP
(5854)

254
(100)

105
(41.3)

92
(36.2)

XP
(5855)

254
(100)

105
(41.3)

92
(36.2)

GTS
(5814)

3b

302
(119)

119
(46.9)

95
(37.4)

GTX
(5862)

3b

302
(119)

119
(46.9)

95
(37.4)

DRY WEIGHT

LOAD LIMIT

FUEL TANK

OIL INJECTION
RESERVOIR

IMPELLER
SHAFT
RESERVOIR

2532201-Book Page 97 Thursday, August 1, 1996 8:17 AM

kg
(lb)

kg
(lb)

L
(U.S. gal)
c

L
(U.S. gal)

mL
(U.S. oz)

176
(388)

160
(353)

34
(9)

4.5
(1.2)

65
(2.2)

180
(397)

160
(353)

34
(9)

4.5
(1.2)

65
(2.2)

178
(392)

160
(353)

34
(9)

4.5
(1.2)

65
(2.2)

187
(412)

160
(353)

34
(9)

4.5
(1.2)

65
(2.2)

187
(412)

160
(353)

34
(9)

4.5
(1.2)

65
(2.2)

210
(463)

225
(496)

33
(8.7)

2.8
(0.7)

65
(2.2)

220
(485)

225
(496)

33
(8.7)

2.8
(0.7)

65
(2.2)

97

NUMBER
OF
PASSENGERS

OVERALL
LENGTH

OVERALL
WIDTH

OVERALL
HEIGHT

2532201-Book Page 98 Thursday, August 1, 1996 8:17 AM

cm
(in)

cm
(in)

cm
(in)

1993

98

SP
(5806)

254
(100)

105
(41.3)

92
(36.2)

SPX
(5807)

254
(100)

105
(41.3)

92
(36.2)

SPI
(5808)

254
(100)

105
(41.3)

92
(36.2)

XP
(5852)

254
(100)

105
(41.3)

92
(36.2)

GTS
(5813)

3b

302
(119)

119
(46.9)

95
(37.4)

GTX
(5861)

3b

302
(119)

119
(46.9)

95
(37.4)

DRY WEIGHT

LOAD LIMIT

FUEL TANK

OIL INJECTION
RESERVOIR

IMPELLER
SHAFT
RESERVOIR

2532201-Book Page 99 Thursday, August 1, 1996 8:17 AM

kg
(lb)

kg
(lb)

L
(U.S. gal)
c

L
(U.S. gal)

mL
(U.S. oz)

167
(368)

160
(353)

33
(8.7)

2.8
(0.7)

65
(2.2)

168
(370)

160
(353)

33
(8.7)

2.8
(0.7)

65
(2.2)

167
(368)

160
(353)

33
(8.7)

2.8
(0.7)

65
(2.2)

169
(373)

160
(353)

34
(9)

4.5
(1.2)

65
(2.2)

210
(463)

225
(496)

33
(8.7)

2.8
(0.7)

65
(2.2)

210
(463)

225
(496)

33
(8.7)

2.8
(0.7)

65
(2.2)

99

NUMBER
OF
PASSENGERS

OVERALL
LENGTH

OVERALL
WIDTH

OVERALL
HEIGHT

2532201-Book Page 100 Thursday, August 1, 1996 8:17 AM

cm
(in)

cm
(in)

cm
(in)

1992
SP
(5805)

244
(96)

105
(41.3)

92
(36.2)

XP
(5851)

244
(96)

105
(41.3)

92
(36.2)

GTS
(5812)

3b

303
(119.3)

121
(47.6)

95
(37.4)

GTX
(5860)

3b

303
(119.3)

121
(47.6)

95
(37.4)

100

DRY WEIGHT

LOAD LIMIT

FUEL TANK

OIL INJECTION
RESERVOIR

IMPELLER
SHAFT
RESERVOIR

2532201-Book Page 101 Thursday, August 1, 1996 8:17 AM

kg
(lb)

kg
(lb)

L
(U.S. gal)
c

L
(U.S. gal)

mL
(U.S. oz)

166
(365)

160
(353)

33
(8.7)

2.8
(0.7)

65
(2.2)

166
(365)

160
(353)

33
(8.7)

2.8
(0.7)

65
(2.2)

209
(461)

225
(496)

33
(8.7)

2.8
(0.7)

65
(2.2)

209
(461)

225
(496)

33
(8.7)

2.8
(0.7)

65
(2.2)

101

NUMBER
OF
PASSENGERS

OVERALL
LENGTH

OVERALL
WIDTH

OVERALL
HEIGHT

2532201-Book Page 102 Thursday, August 1, 1996 8:17 AM

cm
(in)

cm
(in)

cm
(in)

1991
SP
(5804)

244
(96)

105
(41.3)

92
(36.2)

XP
(5850)

244
(96)

105
(41.3)

92
(36.2)

GT
(5811)

303
(119.3)

121
(47.6)

95
(37.4)

102

DRY WEIGHT

LOAD LIMIT

FUEL TANK

OIL INJECTION
RESERVOIR

IMPELLER
SHAFT
RESERVOIR

2532201-Book Page 103 Thursday, August 1, 1996 8:17 AM

kg
(lb)

kg
(lb)

L
(U.S. gal)
c

L
(U.S. gal)

mL
(U.S. oz)

166
(365)

160
(353)

33
(8.7)

2.8
(0.7)

65
(2.2)

166
(365)

160
(353)

33
(8.7)

2.8
(0.7)

65
(2.2)

209
(461)

225
(496)

33
(8.7)

2.8
(0.7)

65
(2.2)

103

NUMBER
OF
PASSENGERS

OVERALL
LENGTH

OVERALL
WIDTH

OVERALL
HEIGHT

2532201-Book Page 104 Thursday, August 1, 1996 8:17 AM

cm
(in)

cm
(in)

cm
(in)

1990
SP
(5803)

244
(96)

105
(41.3)

92
(36.2)

GT
(5810)

303
(119.3)

121
(47.6)

95
(37.4)

104

DRY WEIGHT

LOAD LIMIT

FUEL TANK

OIL INJECTION
RESERVOIR

IMPELLER
SHAFT
RESERVOIR

2532201-Book Page 105 Thursday, August 1, 1996 8:17 AM

kg
(lb)

kg
(lb)

L
(U.S. gal)
c

L
(U.S. gal)

mL
(U.S. oz)

166
(365)

160
(353)

29.1
(7.7)

2.8
(0.7)

65
(2.2)

209
(461)

225
(496)

29.1
(7.7)

2.8
(0.7)

65
(2.2)

105

NUMBER
OF
PASSENGERS

OVERALL
LENGTH

OVERALL
WIDTH

OVERALL
HEIGHT

2532201-Book Page 106 Thursday, August 1, 1996 8:17 AM

cm
(in)

cm
(in)

cm
(in)

244
(96)

105
(41.3)

92
(36.2)

1989
SP
(5802)

106

DRY WEIGHT

LOAD LIMIT

FUEL TANK

OIL INJECTION
RESERVOIR

IMPELLER
SHAFT
RESERVOIR

2532201-Book Page 107 Thursday, August 1, 1996 8:17 AM

kg
(lb)

kg
(lb)

L
(U.S. gal)
c

L
(U.S. gal)

mL
(U.S. oz)

166
(365)

160
(353)

29.1
(7.7)

2.8
(0.7)

60
(2)

107

NUMBER
OF
PASSENGERS

OVERALL
LENGTH

OVERALL
WIDTH

OVERALL
HEIGHT

2532201-Book Page 108 Thursday, August 1, 1996 8:17 AM

cm
(in)

cm
(in)

cm
(in)

244
(96)

105
(41.3)

92
(36.2)

1988
SP
(5801)

108

DRY WEIGHT

LOAD LIMIT

FUEL TANK

OIL INJECTION
RESERVOIR

IMPELLER
SHAFT
RESERVOIR

2532201-Book Page 109 Thursday, August 1, 1996 8:17 AM

kg
(lb)

kg
(lb)

L
(U.S. gal)
c

L
(U.S. gal)

mL
(U.S. oz)

166
(365)

160
(353)

29.1
(7.7)

2.8
(0.7)

80
(2.7)

109

2532201-Book Page 110 Thursday, August 1, 1996 8:17 AM

110

2532201-Book Page 111 Thursday, August 1, 1996 8:17 AM

SECTION CONTENTS

MATERIALS

TABLE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

PAGE
112

Hull
Jet Pump Housing
Stator
Venturi
Nozzle
Air Intake Silencer
Flame Arrester
Tuned Pipe / Muffler
Steering Padding
Fuel Tank
Oil Injection Reservoir
ABBREVIATIONS:
a

Some models are equipped with a thermoplastic elastomer cover.

111

VENTURI

NOZZLE

SP
(5876)

Composite

Aluminum

Aluminum

Plastic

Plastic

SPX
(5877)

Composite

Plastic

Brass
Alloy

Plastic

Aluminum

SPI
(5878)

Composite

Aluminum

Aluminum

Plastic

Plastic

XP
(5858-5859)

Composite

Plastic

Brass
Alloy

Plastic

Aluminum

GSX
(5620)

Composite

Plastic

Brass
Alloy

Plastic

Aluminum

GTS
(5817)

Composite

Aluminum

Aluminum

Plastic

Plastic

GTI
(5865-58665867)

Composite

Plastic

Brass
Alloy

Plastic

Plastic

GTX
(5640)

Composite

Plastic

Brass
Alloy

Plastic

Plastic

HX
(5881)

Composite

Plastic

Brass
Alloy

Plastic

Plastic

HULL

STATOR

JET PUMP HOUSING

2532201-Book Page 112 Thursday, August 1, 1996 8:17 AM

1996

112

OIL INJECTION
RESERVOIR

FUEL TANK

STEERING PADDING

TUNED PIPE / MUFFLER

FLAME ARRESTER

AIR INTAKE SILENCER

2532201-Book Page 113 Thursday, August 1, 1996 8:17 AM

Thermo- Multi-layer
plastic
wire
screen

Aluminum

PolyPolyThermoplastic
elastomer with ethylene ethylene
polystyrene foam

Thermo- Multi-layer
plastic
wire
screen

Aluminum

PolyPolyThermoplastic
elastomer with ethylene ethylene
polystyrene foam

Thermo- Multi-layer
plastic
wire
screen

Aluminum

PolyPolyThermoplastic
elastomer with ethylene ethylene
polystyrene foam

Thermo- Multi-layer
plastic
wire
screen

Aluminum

PolyPolyThermoplastic
elastomer with ethylene ethylene
polystyrene foam

Thermo- Multi-layer
plastic
wire
screen

Aluminum

Thermo- Multi-layer
plastic
wire
screen

Aluminum

PolyPolyThermoplastic
elastomer with ethylene ethylene
polystyrene foam

Thermo- Multi-layer
plastic
wire
screen

Aluminum

PolyPolyThermoplastic
elastomer with ethylene ethylene
polystyrene foam

Thermo- Multi-layer
plastic
wire
screen

Aluminum

Thermo- Multi-layer
plastic
wire
screen

Aluminum

Thermoplastic
elastomer

Thermoplastic
elastomer

PolyPolyethylene ethylene

PolyPolyethylene ethylene

PolyPolyThermoplastic
elastomer with ethylene ethylene
polystyrene foam

113

VENTURI

NOZZLE

SP
(5873)

Composite

Aluminum

Aluminum

Aluminum

Aluminum

SPX
(5874)

Composite

Aluminum

Brass
Alloy

Aluminum

Aluminum

SPI
(5875)

Composite

Aluminum

Aluminum

Aluminum

Aluminum

XP 800
(5856)

Composite

Plastic

Brass
Alloy

Plastic

Aluminum

XP
(5857)

Composite

Aluminum
or
Plastic

Brass
Alloy

Plastic

Aluminum

GTS
(5815-5816)

Composite

Aluminum

Aluminum

Plastic

Plastic

GTX
(5863-5864)

Composite

Aluminum

Brass
Alloy

Plastic

Plastic

HX
(5880)

Composite

Plastic

Brass
Alloy

Plastic

Plastic

HULL

STATOR

JET PUMP HOUSING

2532201-Book Page 114 Thursday, August 1, 1996 8:17 AM

1995

114

OIL INJECTION
RESERVOIR

FUEL TANK

STEERING PADDING

TUNED PIPE / MUFFLER

FLAME ARRESTER

AIR INTAKE SILENCER

2532201-Book Page 115 Thursday, August 1, 1996 8:17 AM

Thermo- Multi-layer
plastic
wire
screen

Aluminum

PolyPolyThermoplastic
elastomer with ethylene ethylene
polystyrene foam

Thermo- Multi-layer
plastic
wire
screen

Aluminum

PolyPolyThermoplastic
elastomer with ethylene ethylene
polystyrene foam

Thermo- Multi-layer
plastic
wire
screen

Aluminum

PolyPolyThermoplastic
elastomer with ethylene ethylene
polystyrene foam

Thermo- Multi-layer
plastic
wire
screen

Aluminum

PolyPolyThermoplastic
elastomer with ethylene ethylene
polystyrene foam

Thermo- Multi-layer
plastic
wire
screen

Aluminum

PolyPolyThermoplastic
elastomer with ethylene ethylene
polystyrene foam

Thermo- Multi-layer
plastic
wire
screen

Aluminum

PolyPolyThermoplastic
elastomer with ethylene ethylene
polystyrene foam

Thermo- Multi-layer
plastic
wire
screen

Aluminum

PolyPolyThermoplastic
elastomer with ethylene ethylene
polystyrene foam

Thermo- Multi-layer
plastic
wire
screen

Aluminum

PolyPolyThermoplastic
elastomer with ethylene ethylene
polystyrene foam

115

VENTURI

NOZZLE

SP
(5870)

Composite

Aluminum

Aluminum

Aluminum

Aluminum

SPX
(5871)

Composite

Aluminum

Brass
Alloy

Aluminum

Aluminum

SPI
(5872)

Composite

Aluminum

Aluminum

Aluminum

Aluminum

XP
(5854)

Composite

Aluminum

Brass
Alloy

Aluminum

Aluminum

XP
(5855)

Composite

Aluminum

Brass
Alloy

Aluminum

Aluminum

GTS
(5814)

Composite

Aluminum

Aluminum

Aluminum

Aluminum

GTX
(5862)

Composite

Aluminum

Brass
Alloy

Aluminum

Aluminum

HULL

STATOR

JET PUMP HOUSING

2532201-Book Page 116 Thursday, August 1, 1996 8:17 AM

1994

116

OIL INJECTION
RESERVOIR

FUEL TANK

STEERING PADDING

TUNED PIPE / MUFFLER

FLAME ARRESTER

AIR INTAKE SILENCER

2532201-Book Page 117 Thursday, August 1, 1996 8:17 AM

Thermo- Multi-layer
plastic
wire
screen

Aluminum

PolyPolyThermoplastic
elastomer with ethylene ethylene
polystyrene foam

Thermo- Multi-layer
plastic
wire
screen

Aluminum

PolyPolyThermoplastic
elastomer with ethylene ethylene
polystyrene foam

Thermo- Multi-layer
plastic
wire
screen

Aluminum

PolyPolyThermoplastic
elastomer with ethylene ethylene
polystyrene foam

Thermo- Multi-layer
plastic
wire
screen

Aluminum

PolyPolyThermoplastic
elastomer with ethylene ethylene
polystyrene foam

Thermo- Multi-layer
plastic
wire
screen

Aluminum

PolyPolyThermoplastic
elastomer with ethylene ethylene
polystyrene foam

Thermo- Multi-layer
plastic
wire
screen

Aluminum

PolyPolyThermoplastic
elastomer with ethylene ethylene
polystyrene foam

Thermo- Multi-layer
plastic
wire
screen

Aluminum

PolyPolyThermoplastic
elastomer with ethylene ethylene
polystyrene foam

117

VENTURI

NOZZLE

SP
(5806)

Composite

Aluminum

Aluminum

Aluminum

Aluminum

SPX
(5807)

Composite

Aluminum

Aluminum

Aluminum

Aluminum

SPI
(5808)

Composite

Aluminum

Aluminum

Aluminum

Aluminum

XP
(5852)

Composite

Aluminum

Brass
Alloy

Aluminum

Aluminum

GTS
(5813)

Composite

Aluminum

Aluminum

Aluminum

Aluminum

GTX
(5861)

Composite

Aluminum

Aluminum

Aluminum

Aluminum

HULL

STATOR

JET PUMP HOUSING

2532201-Book Page 118 Thursday, August 1, 1996 8:17 AM

1993

118

OIL INJECTION
RESERVOIR

FUEL TANK

STEERING PADDING

TUNED PIPE / MUFFLER

FLAME ARRESTER

AIR INTAKE SILENCER

2532201-Book Page 119 Thursday, August 1, 1996 8:17 AM

Thermo- Multi-layer
plastic
wire
screen

Aluminum

PolyPolyThermoplastic
elastomer with ethylene ethylene
polystyrene foam

Thermo- Multi-layer
plastic
wire
screen

Aluminum

PolyPolyThermoplastic
elastomer with ethylene ethylene
polystyrene foam

Thermo- Multi-layer
plastic
wire
screen

Aluminum

PolyPolyThermoplastic
elastomer with ethylene ethylene
polystyrene foam

Thermo- Multi-layer
plastic
wire
screen

Aluminum

PolyPolyThermoplastic
elastomer with ethylene ethylene
polystyrene foam

Thermo- Multi-layer
plastic
wire
screen

Aluminum

PolyPolyThermoplastic
elastomer with ethylene ethylene
polystyrene foam

Thermo- Multi-layer
plastic
wire
screen

Aluminum

PolyPolyThermoplastic
elastomer with ethylene ethylene
polystyrene foam

119

VENTURI

NOZZLE

SP
(5805)

Composite

Aluminum

Aluminum

Aluminum

Aluminum

XP
(5851)

Composite

Aluminum

Aluminum

Aluminum

Aluminum

GTS
(5812)

Composite

Aluminum

Aluminum

Aluminum

Aluminum

GTX
(5860)

Composite

Aluminum

Aluminum

Aluminum

Aluminum

HULL

STATOR

JET PUMP HOUSING

2532201-Book Page 120 Thursday, August 1, 1996 8:17 AM

1992

120

OIL INJECTION
RESERVOIR

FUEL TANK

STEERING PADDING

TUNED PIPE / MUFFLER

FLAME ARRESTER

AIR INTAKE SILENCER

2532201-Book Page 121 Thursday, August 1, 1996 8:17 AM

Thermo- Multi-layer
AluVinyl with
PolyPolyplastic wire screen minum polystyrene foam ethylene ethylene
Thermo- Multi-layer
AluVinyl with
PolyPolyplastic wire screen minum polystyrene foam ethylene ethylene
Thermo- Multi-layer
AluVinyl with
PolyPolyplastic wire screen minum polystyrene foam ethylene ethylene
Thermo- Multi-layer
AluVinyl with
PolyPolyplastic wire screen minum polystyrene foam ethylene ethylene

121

VENTURI

NOZZLE

SP
(5804)

Composite

Aluminum

Aluminum

Aluminum

Aluminum

XP
(5850)

Composite

Aluminum

Aluminum

Aluminum

Aluminum

GT
(5811)

Composite

Aluminum

Aluminum

Aluminum

Aluminum

HULL

STATOR

JET PUMP HOUSING

2532201-Book Page 122 Thursday, August 1, 1996 8:17 AM

1991

122

OIL INJECTION
RESERVOIR

FUEL TANK

STEERING PADDING

TUNED PIPE / MUFFLER

FLAME ARRESTER

AIR INTAKE SILENCER

2532201-Book Page 123 Thursday, August 1, 1996 8:17 AM

Thermo- Multi-layer
AluVinyl with
PolyPolyplastic wire screen minum polystyrene foam ethylene ethylene
Thermo- Multi-layer
AluVinyl with
PolyPolyplastic wire screen minum polystyrene foam ethylene ethylene
Thermo- Multi-layer
AluVinyl with
PolyPolyplastic wire screen minum polystyrene foam ethylene ethylene

123

VENTURI

NOZZLE

SP
(5803)

Composite

Aluminum

Aluminum

Aluminum

Aluminum

GT
(5810)

Composite

Aluminum

Aluminum

Aluminum

Aluminum

HULL

STATOR

JET PUMP HOUSING

2532201-Book Page 124 Thursday, August 1, 1996 8:17 AM

1990

124

OIL INJECTION
RESERVOIR

FUEL TANK

Aluminum
foam

STEERING PADDING

FLAME ARRESTER

Thermoplastic

TUNED PIPE / MUFFLER

AIR INTAKE SILENCER

2532201-Book Page 125 Thursday, August 1, 1996 8:17 AM

AluVinyl with
PolyPolyminum polystyrene foam ethylene ethylene

Thermo- Multi-layer
AluVinyl with
PolyPolyplastic wire screen minum polystyrene foam ethylene ethylene

125

STATOR

VENTURI

NOZZLE

JET PUMP HOUSING

HULL

2532201-Book Page 126 Thursday, August 1, 1996 8:17 AM

Aluminum

Aluminum

Aluminum

1989
SP
(5802)

126

Composite

Aluminum

OIL INJECTION
RESERVOIR

FUEL TANK

Aluminum
foam

STEERING PADDING

FLAME ARRESTER

Thermoplastic

TUNED PIPE / MUFFLER

AIR INTAKE SILENCER

2532201-Book Page 127 Thursday, August 1, 1996 8:17 AM

AluVinyl with
PolyPolyminum polystyrene foam ethylene ethylene

127

STATOR

VENTURI

NOZZLE

JET PUMP HOUSING

HULL

2532201-Book Page 128 Thursday, August 1, 1996 8:17 AM

Aluminum

Aluminum

Aluminum

1988
SP
(5801)

128

Composite

Aluminum

OIL INJECTION
RESERVOIR

FUEL TANK

Aluminum
foam

STEERING PADDING

FLAME ARRESTER

Thermoplastic

TUNED PIPE / MUFFLER

AIR INTAKE SILENCER

2532201-Book Page 129 Thursday, August 1, 1996 8:17 AM

AluVinyl with
PolyPolyminum polystyrene foam ethylene ethylene

129

2532201-Book Page 130 Thursday, August 1, 1996 8:17 AM

130

2532201-Book Page 131 Thursday, August 1, 1996 8:17 AM

SECTION CONTENTS

ENGINE TIGHTENING TORQUES

TABLE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

PAGE
132

Exhaust Manifold Screws

Magneto Flywheel Nut
Flywheel (PTO Side)
Crankcase Screws (M8)
Crankcase Screws (M10)
Crankcase / Engine Support Nuts
Engine Support Screws
Cylinder Head Screws
Cylinder Head Cover Screws
Crankcase / Cylinder Screws
Tuned Pipe Screws / Nut
Flame Arrester Screws
Magneto Housing Cover Screws
Starter Screws
Spark Plugs
ABBREVIATIONS:
N.A.: Not Applicable
a

Loctite 242 (blue).

Loctite 271 (red).

Loctite 515.

Synthetic Grease.

Anti-seize Lubricant.

To convert lbfft to lbfin multiply by 12.

Cylinder head screws secure also cylinder head cover.

Tuned Pipe Flange.

131

EXHAUST
MANIFOLD
SCREWS

MAGNETO
FLYWHEEL NUT

PTO FLYWHEEL

CRANKCASE
SCREWS

CRANKCASE
SCREWS

CRANKCASE /
ENGINE
SUPPORT NUTS

2532201-Book Page 132 Thursday, August 1, 1996 8:17 AM

M8

M10

SP
(5876)

24 (17)
d

145
(107)

110
(81)

24 (17) 40 (30)
cd
cd

35
(26)

SPX
(5877)

24 (17)
d

145
(107)

110
(81)

24 (17) 40 (30)
cd
cd

35
(26)

SPI
(5878)

24 (17)
d

145
(107)

110
(81)

24 (17) 40 (30)
cd
cd

35
(26)

XP
(5858-5859)

40 (30)
cd

105
(77)

110
(81)

24 (17) 40 (30)
cd
cd

N.A.

GSX
(5620)

40 (30)
cd

105
(77)

110
(81)

24 (17) 40 (30)
cd
cd

N.A.

GTS
(5817)

24 (17)
d

145
(107)

110
(81)

24 (17) 40 (30)
cd
cd

35
(26)

GTI
(5865-58665867)

24 (17)
d

145
(107)

110
(81)

24 (17) 40 (30)
cd
cd

35
(26)

GTX
(5640)

40 (30)
cd

105
(77)

110
(81)

24 (17) 40 (30)
cd
cd

N.A.

HX
(5881)

24 (17)
d

145
(107)

110
(81)

24 (17) 40 (30)
cd
cd

35
(26)

1996

132

FLAME ARRESTER
SCREWS

MAGNETO
HOUSING
COVER SCREWS

STARTER
SCREWS

SPARK PLUGS

TUNED PIPE
SCREWS / NUT

CRANKCASE /
CYLINDER
SCREWS

CYLINDER HEAD
COVER SCREWS

CYLINDER HEAD
SCREWS

ENGINE SUPPORT
SCREWS

2532201-Book Page 133 Thursday, August 1, 1996 8:17 AM

25
(18)

24 (17)
d

9
(7)

24 (17)
d

25
(18)

10
(7)

9
(7)

22 (16)

24
(17)

25
(18)

24 (17)
ad

24 (17)
ad

25
(18)

10
(7)

9
(7)

22 (16)

24
(17)

25
(18)

24 (17)
d

9
(7)

24 (17)
d

25
(18)

10
(7)

9
(7)

22 (16)

24
(17)

25
(18)

24 (17)
ad

40 (30) 25 (18)
cd
40 (30)
h

10
(7)

9
(7)

22 (16)

24
(17)

25
(18)

24 (17)
ad

40 (30) 25 (18)
cd
40 (30)
h

10
(7)

9
(7)

22 (16)

24
(17)

25
(18)

24 (17)
d

9
(7)

24 (17)
d

25
(18)

10
(7)

9
(7)

22 (16)

24
(17)

25
(18)

24 (17)
ad

9
(7)

24 (17)
ad

25
(18)

10
(7)

9
(7)

22 (16)

24
(17)

25
(18)

24 (17)
ad

40 (30) 25 (18)
cd
40 (30)
h

10
(7)

9
(7)

22 (16)

24
(17)

25
(18)

24 (17)
ad

24 (17)
ad

10
(7)

9
(7)

22 (16)

24
(17)

25
(18)

133

MAGNETO
FLYWHEEL NUT

FLYWHEEL

CRANKCASE
SCREWS

CRANKCASE
SCREWS

CRANKCASE /
ENGINE
SUPPORT NUTS

EXHAUST
MANIFOLD
SCREWS

2532201-Book Page 134 Thursday, August 1, 1996 8:17 AM

PTO
SIDE

M8

M10

1995
SP
(5873)

24 (17)
d

145
(107)

110
(81)

24 (17) 40 (30)
cd
cd

35
(26)

SPX
(5874)

24 (17)
d

145
(107)

110
(81)

24 (17) 40 (30)
cd
cd

35
(26)

SPI
(5875)

24 (17)
d

145
(107)

110
(81)

24 (17) 40 (30)
cd
cd

35
(26)

XP 800
(5856)

38 (28)
c

105
(77)

110
(81)

24 (17) 40 (30)
cd
cd

N.A.

XP
(5857)

24 (17)
d

145
(107)

110
(81)

24 (17) 40 (30)
cd
cd

35
(26)

GTS
(5815-5816)

24 (17)
d

145
(107)

110
(81)

24 (17) 40 (30)
cd
cd

35
(26)

GTX
(5863-5864)

24 (17)
d

145
(107)

110
(81)

24 (17) 40 (30)
cd
cd

35
(26)

HX
(5880)

24 (17)
d

145
(107)

110
(81)

24 (17) 40 (30)
cd
cd

35
(26)

134

FLAME ARRESTER
SCREWS

MAGNETO
HOUSING
COVER SCREWS

STARTER
SCREWS

SPARK PLUGS

TUNED PIPE
SCREWS / NUT

CRANKCASE /
CYLINDER
SCREWS

CYLINDER HEAD
COVER SCREWS

CYLINDER HEAD
SCREWS

ENGINE SUPPORT
SCREWS

2532201-Book Page 135 Thursday, August 1, 1996 8:17 AM

25
(18)

24 (17)
d

9
(7)

24 (17)
d

25
(18)

10
(7)

9
(7)

22 (16)

24
(17)

25
(18)

24 (17)
ad

24 (17)
ad

25
(18)

10
(7)

9
(7)

22 (16)

24
(17)

25
(18)

24 (17)
d

9
(7)

24 (17)
d

25
(18)

10
(7)

9
(7)

22 (16)

24
(17)

25
(18)

24 (17)
ad

40 (30) 25 (18)
cd
40 (30)
h

10
(7)

9
(7)

22 (16)

24
(17)

25
(18)

24 (17)
ad

24 (17)
ad

25
(18)

10
(7)

9
(7)

22 (16)

24
(17)

25
(18)

24 (17)
d

9
(7)

24 (17)
d

25
(18)

10
(7)

9
(7)

22 (16)

24
(17)

25
(18)

24 (17)
ad

24 (17)
ad

25
(18)

10
(7)

9
(7)

22 (16)

24
(17)

25
(18)

24 (17)
ad

24 (17)
ad

25
(18)

10
(7)

9
(7)

22 (16)

24
(17)

135

MAGNETO
FLYWHEEL NUT

FLYWHEEL

CRANKCASE
SCREWS

CRANKCASE
SCREWS

CRANKCASE /
ENGINE
SUPPORT NUTS

EXHAUST
MANIFOLD
SCREWS

2532201-Book Page 136 Thursday, August 1, 1996 8:17 AM

PTO
SIDE

M8

M10

1994
SP
(5870)

24 (17)
d

145
(107)

110
(81)

22 (16) 38 (28)
cd
ad

35
(26)

SPX
(5871)

24 (17)
d

145
(107)

110
(81)

22 (16) 38 (28)
cd
ac

35
(26)

SPI
(5872)

24 (17)
d

145
(107)

110
(81)

22 (16) 38 (28)
cd
ad

35
(26)

XP
(5854)

24 (17)
d

145
(107)

110
(81)

22 (16) 40 (30)
cd
ac

35
(26)

XP
(5855)

24 (17)
d

145
(107)

110
(81)

22 (16) 38 (28)
cd
ac

35
(26)

GTS
(5814)

24 (17)
d

145
(107)

110
(81)

22 (16) 38 (28)
cd
ad

35
(26)

GTX
(5862)

24 (17)
d

145
(107)

110
(81)

22 (16) 38 (28)
cd
ac

35
(26)

136

FLAME ARRESTER
SCREWS

MAGNETO
HOUSING
COVER SCREWS

STARTER
SCREWS

SPARK PLUGS

TUNED PIPE
SCREWS / NUT

CRANKCASE /
CYLINDER
SCREWS

CYLINDER HEAD
COVER SCREWS

CYLINDER HEAD
SCREWS

ENGINE SUPPORT
SCREWS

2532201-Book Page 137 Thursday, August 1, 1996 8:17 AM

25
(18)

22 (16)
d

9
(7)

22 (16)
d

25
(18)

10
(7)

5
(4)

22 (16)

24
(17)

25
(18)

22 (16)
ad

22 (16)
ad

25
(18)

10
(7)

5
(4)

22 (16)

24
(17)

25
(18)

22 (16)
d

9
(7)

22 (16)
d

25
(18)

10
(7)

5
(4)

22 (16)

24
(17)

25
(18)

22 (16)
ad

22 (16)
ad

25
(18)

10
(7)

5
(4)

22 (16)

24
(17)

25
(18)

22 (16)
ad

22 (16)
ad

25
(18)

10
(7)

5
(4)

22 (16)

24
(17)

25
(18)

22 (16)
d

9
(7)

22 (16)
d

25
(18)

10
(7)

5
(4)

22 (16)

24
(17)

25
(18)

22 (16)
ad

22 (16)
ad

25
(18)

10
(7)

5
(4)

22 (16)

24
(17)

137

MAGNETO
FLYWHEEL NUT

FLYWHEEL

CRANKCASE
SCREWS

CRANKCASE
SCREWS

CRANKCASE /
ENGINE
SUPPORT NUTS

EXHAUST
MANIFOLD
SCREWS

2532201-Book Page 138 Thursday, August 1, 1996 8:17 AM

PTO
SIDE

M8

M10

1993
SP
(5806)

20
(15)

105
(77)

110
(81)

22 (16) 38 (28)
cd
cd

35
(26)

SPX
(5807)

20
(15)

105
(77)

110
(81)

22 (16) 38 (28)
cd
cd

35
(26)

SPI
(5808)

20
(15)

105
(77)

110
(81)

22 (16) 38 (28)
cd
cd

35
(26)

XP
(5852)

20
(15)

105
(77)

110
(81)

22 (16) 40 (30)
cd
cd

35
(26)

GTS
(5813)

20
(15)

105
(77)

110
(81)

22 (16) 38 (28)
cd
cd

35
(26)

GTX
(5861)

20
(15)

105
(77)

110
(81)

22 (16) 38 (28)
cd
cd

35
(26)

138

FLAME ARRESTER
SCREWS

MAGNETO
HOUSING
COVER SCREWS

STARTER
SCREWS

SPARK PLUGS

TUNED PIPE
SCREWS / NUT

CRANKCASE /
CYLINDER
SCREWS

CYLINDER HEAD
COVER SCREWS

CYLINDER HEAD
SCREWS

ENGINE SUPPORT
SCREWS

2532201-Book Page 139 Thursday, August 1, 1996 8:17 AM

25
(18)

20 (15)
d

9
(7)

20 (15)
d

25
(18)

10
(7)

5
(4)

22 (16)

24
(17)

25
(18)

20 (15)
d

9
(7)

20 (15)
d

25
(18)

10
(7)

5
(4)

22 (16)

24
(17)

25
(18)

20 (15)
d

9
(7)

20 (15)
d

25
(18)

10
(7)

5
(4)

22 (16)

24
(17)

25
(18)

22 (16)
d

22 (16)
ad

25
(18)

10
(7)

5
(4)

22 (16)

24
(17)

25
(18)

20 (15)
d

9
(7)

20 (15)
d

25
(18)

10
(7)

5
(4)

22 (16)

24
(17)

25
(18)

20 (15)
d

9
(7)

20 (15)
d

25
(18)

10
(7)

5
(4)

22 (16)

24
(17)

139

MAGNETO
FLYWHEEL NUT

FLYWHEEL

CRANKCASE
SCREWS

CRANKCASE
SCREWS

CRANKCASE /
ENGINE
SUPPORT NUTS

EXHAUST
MANIFOLD
SCREWS

2532201-Book Page 140 Thursday, August 1, 1996 8:17 AM

PTO
SIDE

M8

M10

1992
SP
(5805)

20
(15)

105
(77)

110
(81)

22 (16) 38 (28)

35
(26)

XP
(5851)

20
(15)

105
(77)

110
(81)

22 (16) 38 (28)

35
(26)

GTS
(5812)

20
(15)

105
(77)

110
(81)

22 (16) 38 (28)

35
(26)

GTX
(5860)

20
(15)

105
(77)

110
(81)

22 (16) 38 (28)

35
(26)

140

FLAME ARRESTER
SCREWS

MAGNETO
HOUSING
COVER SCREWS

STARTER
SCREWS

SPARK PLUGS

TUNED PIPE
SCREWS / NUTS

CRANKCASE /
CYLINDER
SCREWS

CYLINDER HEAD
COVER SCREWS

CYLINDER HEAD
SCREWS

ENGINE SUPPORT
SCREWS

2532201-Book Page 141 Thursday, August 1, 1996 8:17 AM

25
(18)

20 (15)
d

9
(7)

20 (15)
d

25
(18)

10
(7)

4
(3)

22 (16)

24
(17)

25
(18)

20 (15)
d

9
(7)

20 (15)
d

25
(18)

10
(7)

4
(3)

22 (16)

24
(17)

25
(18)

20 (15)
d

9
(7)

20 (15)
d

25
(18)

10
(7)

4
(3)

22 (16)

24
(17)

25
(18)

20 (15)
d

9
(7)

20 (15)
d

25
(18)

10
(7)

4
(3)

22 (16)

24
(17)

141

MAGNETO
FLYWHEEL NUT

FLYWHEEL

CRANKCASE
SCREWS

CRANKCASE
SCREWS

CRANKCASE /
ENGINE
SUPPORT NUTS

EXHAUST
MANIFOLD
SCREWS

2532201-Book Page 142 Thursday, August 1, 1996 8:17 AM

PTO
SIDE

M8

M10

1991
SP
(5804)

20
(15)

105
(77)

110
(81)

22 (16)
a

N.A.

35
(26)

XP
(5850)

20
(15)

105
(77)

110
(81)

22 (16)
a

N.A.

35
(26)

GT
(5811)

20
(15)

105
(77)

110
(81)

22 (16)
a

N.A.

35
(26)

142

FLAME ARRESTER
SCREWS

MAGNETO
HOUSING
COVER SCREWS

STARTER
SCREWS

SPARK PLUGS

TUNED PIPE
SCREWS / NUTS

CRANKCASE /
CYLINDER
SCREWS

CYLINDER HEAD
COVER SCREWS

CYLINDER HEAD
SCREWS

ENGINE SUPPORT
SCREWS

2532201-Book Page 143 Thursday, August 1, 1996 8:17 AM

25
(18)

20 (15)
d

9
(7)

20 (15)
d

25
(18)

10
(7)

4
(3)

22 (16)

24
(17)

25
(18)

20 (15)
d

9
(7)

20 (15)
d

25
(18)

10
(7)

4
(3)

22 (16)

24
(17)

25
(18)

20 (15)
d

9
(7)

20 (15)
d

25
(18)

10
(7)

4
(3)

22 (16)

24
(17)

143

MAGNETO
FLYWHEEL NUT

FLYWHEEL

CRANKCASE
SCREWS

CRANKCASE
SCREWS

CRANKCASE /
ENGINE
SUPPORT NUTS

EXHAUST
MANIFOLD
SCREWS

2532201-Book Page 144 Thursday, August 1, 1996 8:17 AM

PTO
SIDE

M8

M10

1990
SP
(5803)

20
(15)

105
(77)

110
(81)

22 (16)
a

N.A.

35
(26)

GT
(5810)

20
(15)

105
(77)

110
(81)

22 (16)
a

N.A.

35
(26)

144

FLAME ARRESTER
SCREWS

MAGNETO
HOUSING
COVER SCREWS
STARTER
SCREWS
SPARK PLUGS

TUNED PIPE
SCREWS / NUTS

CRANKCASE /
CYLINDER
SCREWS

CYLINDER HEAD
COVER SCREWS

CYLINDER HEAD
SCREWS

ENGINE SUPPORT
SCREWS

2532201-Book Page 145 Thursday, August 1, 1996 8:17 AM

a
a
e
a
e

25
(18)
20 (15)
c
9
(7)
20 (15)
d
25
(18)
10
(7)
4
(3)
22 (16)
24
(17)

25
(18)
20 (15)
c
9
(7)
20 (15)
d
25
(18)
10
(7)
4
(3)
22 (16)
24
(17)

145

MAGNETO
FLYWHEEL NUT

FLYWHEEL

CRANKCASE
SCREWS

CRANKCASE
SCREWS

CRANKCASE /
ENGINE
SUPPORT NUTS

EXHAUST
MANIFOLD
SCREWS

2532201-Book Page 146 Thursday, August 1, 1996 8:17 AM

PTO
SIDE

M8

M10

105
(77)

110
(81)

22 (16)
a

N.A.

35
(26)

1989
SP
(5802)

146

20
(15)

25
(18)
20 (15)
c
9
(7)

MAGNETO
HOUSING
COVER SCREWS
STARTER
SCREWS
SPARK PLUGS

20 (15)
ac

FLAME ARRESTER
SCREWS

TUNED PIPE
SCREWS / NUTS

CRANKCASE /
CYLINDER
SCREWS

CYLINDER HEAD
COVER SCREWS

CYLINDER HEAD
SCREWS

ENGINE SUPPORT
SCREWS

2532201-Book Page 147 Thursday, August 1, 1996 8:17 AM

a
a
e
a
e

25
(18)
10
(7)
4
(3)
22 (16)
24
(17)

147

MAGNETO
FLYWHEEL NUT

FLYWHEEL

CRANKCASE
SCREWS

CRANKCASE
SCREWS

CRANKCASE /
ENGINE
SUPPORT NUTS

EXHAUST
MANIFOLD
SCREWS

2532201-Book Page 148 Thursday, August 1, 1996 8:17 AM

PTO
SIDE

M8

M10

105
(77)

110
(81)

22 (16)
a

N.A.

35
(26)

1988
SP
(5801)

148

20
(15)

25
(18)

MAGNETO
HOUSING
COVER SCREWS
STARTER
SCREWS
SPARK PLUGS

20 (15) N.A. 20 (15)

c
ac

FLAME ARRESTER
SCREWS

TUNED PIPE
SCREWS / NUTS

CRANKCASE /
CYLINDER
SCREWS

CYLINDER HEAD
COVER SCREWS

CYLINDER HEAD
SCREWS

ENGINE SUPPORT
SCREWS

2532201-Book Page 149 Thursday, August 1, 1996 8:17 AM

a
a
e
a
e

25
(18)
10
(7)
4
(3)
22 (16)
24
(17)

149

2532201-Book Page 150 Thursday, August 1, 1996 8:17 AM

150

2532201-Book Page 151 Thursday, August 1, 1996 8:17 AM

SECTION CONTENTS

PROPULSION AND STEERING

TIGHTENING TORQUES

TABLE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

PAGE
152

Impeller
Jet Pump Housing Nuts
Venturi Screws
Nozzle Screws
Jet Pump Housing Cover Screws
Inlet Grate Screws
Ride Shoe Screws
Front Steering Support
Rear Steering Support
Handlebar Clamp Bolts
Steering Stem Arm Bolt(s)
Ball Joint Bolt
ABBREVIATIONS:
N.A.: Not Applicable
a

Loctite 242 (Blue).

Loctite 271 (Red).

Loctite 515.

Synthetic Grease.

Antiseize Lubricant.

7 Nm (62 lbfin) for aluminum covers.

To convert lbfft to lbfin multiply by 12.

If equipped with a plastic nozzle,

torque to 2 Nm (18 lbfin).

151

IMPELLER

JET PUMP
HOUSING NUTS

VENTURI
SCREWS

NOZZLE
SCREWS

JET PUMP
HOUSING COVER
SCREWS

2532201-Book Page 152 Thursday, August 1, 1996 8:17 AM

SP
(5876)

70 (52)

35 (26)

25 (18)

20 (15)

4 (3)

SPX
(5877)

70 (52)

35 (26)

25 (18)

14 (10)

7 (5)

SPI
(5878)

70 (52)

35 (26)

25 (18)

20 (15)

4 (3)

XP
(5858-5859)

70 (52)

35 (26)

21 (16)

14 (10)

4 (3)

GSX
(5620)

70 (52)

31 (23)

21 (16)

14 (10)

4 (3)

GTS
(5817)

70 (52)

35 (26)

21 (16)

20 (15)

4 (3)

GTI
(5865-58665867)

70 (52)

35 (26)

21 (16)

20 (15)

4 (3)

GTX
(5640)

70 (52)

31 (23)

21 (16)

20 (15)

4 (3)

HX
(5881)

70 (52)

31 (23)

21 (16)

14 (10)

4 (3)

1996

152

RIDE SHOE
SCREWS

FRONT STEERING
SUPPORT

REAR STEERING
SUPPORT

HANDLEBAR
CLAMP BOLTS

STEERING STEM
ARM BOLT(S)

8 (6)

10 (7)

15 (11)

15 (11)

26 (19)

6 (4)

7 (5)
h

8 (6)

10 (7)

15 (11)

15 (11)

26 (19)

6 (4)

7 (5)

8 (6)

10 (7)

15 (11)

15 (11)

26 (19)

6 (4)

2 (1.5)

8 (6)

10 (7)

15 (11)

15 (11)

26 (19)

6 (4)

7 (5)

8 (6)

22 (16)

15 (11)

7 (5)

26 (19)

6 (4)

7 (5)

8 (6)

10 (7)

7 (5)

15 (11)

26 (19)

40 (30)
b

2 (1.5)

8 (6)

10 (7)

7 (5)

15 (11)

26 (19)

40 (30)
b

2 (1.5)

8 (6)

22 (16)

15 (11)

7 (5)

26 (19)

6 (4)

2 (1.5)

8 (6)

10 (7)

15 (11)

6 (4)

26 (19)

6 (4)

7 (5)

BALL JOINT
BOLT

INLET GRATE
SCREWS

2532201-Book Page 153 Thursday, August 1, 1996 8:17 AM

153

IMPELLER

JET PUMP
HOUSING NUTS

VENTURI
SCREWS

NOZZLE
SCREWS

JET PUMP
HOUSING COVER
SCREWS

2532201-Book Page 154 Thursday, August 1, 1996 8:17 AM

SP
(5873)

70 (52)

35 (26)

25 (18)

20 (15)

4 (3)
f

SPX
(5874)

70 (52)

35 (26)

25 (18)

14 (10)

4 (3)

SPI
(5875)

70 (52)

35 (26)

25 (18)

20 (15)

4 (3)
f

XP 800
(5856)

70 (52)

35 (26)

21 (16)

14 (10)

4 (3)

XP
(5857)

70 (52)

35 (26)

21 (16)

14 (10)

4 (3)

GTS
(5815-5816)

70 (52)

35 (26)

21 (16)

20 (15)

4 (3)

GTX
(5863-5864)

70 (52)

35 (26)

21 (16)

20 (15)

4 (3)

HX
(5880)

70 (52)

30 (22)

21 (16)

14 (10)

4 (3)

1995

154

INLET GRATE
SCREWS

RIDE SHOE
SCREWS

FRONT STEERING
SUPPORT

REAR STEERING
SUPPORT

HANDLEBAR
CLAMP BOLTS

STEERING STEM
ARM BOLT(S)

BALL JOINT
BOLT

2532201-Book Page 155 Thursday, August 1, 1996 8:17 AM

8 (6)

10 (7)

15 (11)

15 (11)

26 (19)

6 (4)

7 (5)

8 (6)

10 (7)

15 (11)

15 (11)

26 (19)

6 (4)

7 (5)

8 (6)

10 (7)

15 (11)

15 (11)

26 (19)

6 (4)

7 (5)

8 (6)

10 (7)

15 (11)

15 (11)

26 (19)

6 (4)

7 (5)

8 (6)

10 (7)

15 (11)

15 (11)

26 (19)

6 (4)

7 (5)

8 (6)

10 (7)

N.A.

15 (11)

26 (19)

40 (30)
b

7 (5)

8 (6)

10 (7)

N.A.

15 (11)

26 (19)

40 (30)
b

7 (5)

8 (6)

10 (7)

N.A.

15 (11)

26 (19)

6 (4)

7 (5)

155

IMPELLER

JET PUMP
HOUSING NUTS

VENTURI
SCREWS

NOZZLE
SCREWS

JET PUMP
HOUSING COVER
SCREWS

2532201-Book Page 156 Thursday, August 1, 1996 8:17 AM

SP
(5870)

70 (52)

35 (26)

25 (18)

20 (15)

7 (5)

SPX
(5871)

70 (52)

35 (26)

25 (18)

20 (15)

7 (5)

SPI
(5872)

70 (52)

35 (26)

25 (18)

20 (15)

7 (5)

XP
(5854)

70 (52)

35 (26)

25 (18)

20 (15)

7 (5)

XP
(5855)

70 (52)

35 (26)

25 (18)

20 (15)

7 (5)

GTS
(5814)

70 (52)

35 (26)

25 (18)

20 (15)

7 (5)

GTX
(5862)

70 (52)

35 (26)

25 (18)

20 (15)

7 (5)

1994

156

INLET GRATE
SCREWS

RIDE SHOE
SCREWS

FRONT STEERING
SUPPORT

REAR STEERING
SUPPORT

HANDLEBAR
CLAMP BOLTS

STEERING STEM
ARM BOLT(S)

BALL JOINT
BOLT

2532201-Book Page 157 Thursday, August 1, 1996 8:17 AM

8 (6)

10 (7)

15 (11)

15 (11)

26 (19)

6 (4)

7 (5)

8 (6)

10 (7)

15 (11)

15 (11)

26 (19)

6 (4)

7 (5)

8 (6)

10 (7)

15 (11)

15 (11)

26 (19)

6 (4)

7 (5)

8 (6)

10 (7)

15 (11)

15 (11)

26 (19)

6 (4)

7 (5)

8 (6)

10 (7)

15 (11)

15 (11)

26 (19)

6 (4)

7 (5)

8 (6)

10 (7)

N.A.

15 (11)

26 (19)

40 (30)
b

7 (5)

8 (6)

10 (7)

N.A.

15 (11)

26 (19)

40 (30)
b

7 (5)

157

IMPELLER

JET PUMP
HOUSING NUTS

VENTURI
SCREWS

NOZZLE
SCREWS

JET PUMP
HOUSING COVER
SCREWS

2532201-Book Page 158 Thursday, August 1, 1996 8:17 AM

SP
(5806)

70 (52)

35 (26)

25 (18)

20 (15)

7 (5)

SPX
(5807)

70 (52)

35 (26)

25 (18)

20 (15)

7 (5)

SPI
(5808)

70 (52)

35 (26)

25 (18)

20 (15)

7 (5)

XP
(5852)

70 (52)

35 (26)

25 (18)

20 (15)

7 (5)

GTS
(5813)

70 (52)

35 (26)

25 (18)

20 (15)

7 (5)

GTX
(5861)

70 (52)

35 (26)

25 (18)

20 (15)

7 (5)

1993

158

RIDE SHOE
SCREWS

FRONT STEERING
SUPPORT

REAR STEERING
SUPPORT

HANDLEBAR
CLAMP BOLTS

STEERING STEM
ARM BOLT(S)

8 (6)

10 (7)

N.A.

15 (11)

26 (19)

40 (30)
b

7 (5)

8 (6)

10 (7)

N.A.

15 (11)

26 (19)

40 (30)
b

7 (5)

8 (6)

10 (7)

N.A.

15 (11)

26 (19)

40 (30)
b

7 (5)

8 (6)

10 (7)

15 (11)

15 (11)

26 (19)

6 (4)

7 (5)

8 (6)

10 (7)

N.A.

15 (11)

26 (19)

40 (30)
b

7 (5)

8 (6)

10 (7)

N.A.

15 (11)

26 (19)

40 (30)
b

7 (5)

BALL JOINT
BOLT

INLET GRATE
SCREWS

2532201-Book Page 159 Thursday, August 1, 1996 8:17 AM

159

IMPELLER

JET PUMP
HOUSING NUTS

VENTURI
SCREWS

NOZZLE
SCREWS

JET PUMP
HOUSING COVER
SCREWS

2532201-Book Page 160 Thursday, August 1, 1996 8:17 AM

SP
(5805)

70 (52)

35 (26)

25 (18)

20 (15)

7 (5)

XP
(5851)

70 (52)

35 (26)

25 (18)

20 (15)

7 (5)

GTS
(5812)

70 (52)

35 (26)

25 (18)

20 (15)

7 (5)

GTX
(5860)

70 (52)

35 (26)

25 (18)

20 (15)

7 (5)

1992

160

RIDE SHOE
SCREWS

FRONT STEERING
SUPPORT

REAR STEERING
SUPPORT

HANDLEBAR
CLAMP BOLTS

STEERING STEM
ARM BOLT(S)

8 (6)

10 (7)

N.A.

15 (11)

26 (19)

40 (30)
b

7 (5)

8 (6)

10 (7)

N.A.

15 (11)

26 (19)

40 (30)
b

7 (5)

8 (6)

10 (7)

N.A.

15 (11)

26 (19)

40 (30)
b

7 (5)

8 (6)

10 (7)

N.A.

15 (11)

26 (19)

40 (30)
b

7 (5)

BALL JOINT
BOLT

INLET GRATE
SCREWS

2532201-Book Page 161 Thursday, August 1, 1996 8:17 AM

161

IMPELLER

JET PUMP
HOUSING NUTS

VENTURI
SCREWS

NOZZLE
SCREWS

JET PUMP
HOUSING COVER
SCREWS

2532201-Book Page 162 Thursday, August 1, 1996 8:17 AM

SP
(5804)

70 (52)

35 (26)

25 (18)

20 (15)

7 (5)

XP
(5850)

70 (52)

35 (26)

25 (18)

20 (15)

7 (5)

GT
(5811)

70 (52)

35 (26)

25 (18)

20 (15)

7 (5)

1991

162

RIDE SHOE
SCREWS

FRONT STEERING
SUPPORT

REAR STEERING
SUPPORT

HANDLEBAR
CLAMP BOLTS

STEERING STEM
ARM BOLT(S)

8 (6)

10 (7)

N.A.

15 (11)

26 (19)

40 (30)
b

8 (6)

8 (6)

10 (7)

N.A.

15 (11)

26 (19)

40 (30)
b

8 (6)

8 (6)

10 (7)

N.A.

15 (11)

26 (19)

40 (30)
b

8 (6)

BALL JOINT
BOLT

INLET GRATE
SCREWS

2532201-Book Page 163 Thursday, August 1, 1996 8:17 AM

163

IMPELLER

JET PUMP
HOUSING NUTS

VENTURI
SCREWS

NOZZLE
SCREWS

JET PUMP
HOUSING COVER
SCREWS

2532201-Book Page 164 Thursday, August 1, 1996 8:17 AM

SP
(5803)

70 (52)

35 (26)

25 (18)

20 (15)

7 (5)

GT
(5810)

70 (52)

35 (26)

25 (18)

20 (15)

7 (5)

1990

164

INLET GRATE
SCREWS

RIDE SHOE
SCREWS

FRONT STEERING
SUPPORT

REAR STEERING
SUPPORT

HANDLEBAR
CLAMP BOLTS

STEERING STEM
ARM BOLT(S)

BALL JOINT
BOLT

2532201-Book Page 165 Thursday, August 1, 1996 8:17 AM

8 (6)

10 (7)

N.A.

15 (11)

26 (19)

26 (19)

8 (6)

8 (6)

10 (7)

N.A.

15 (11)

26 (19)

26 (19)

8 (6)

165

IMPELLER

JET PUMP
HOUSING NUTS

VENTURI
SCREWS

NOZZLE
SCREWS

JET PUMP
HOUSING COVER
SCREWS

2532201-Book Page 166 Thursday, August 1, 1996 8:17 AM

44 (32)

25 (18)

20 (15)

20 (15)

8 (6)

1989
SP
(5802)

166

REAR STEERING
SUPPORT

a
a

20 (15)
10 (7)
N.A.
15 (11)

BALL JOINT
BOLT

FRONT STEERING
SUPPORT

STEERING STEM
ARM BOLT(S)

RIDE SHOE
SCREWS

HANDLEBAR
CLAMP BOLTS

INLET GRATE
SCREWS

2532201-Book Page 167 Thursday, August 1, 1996 8:17 AM

26 (19)
26 (19)
8 (6)

167

IMPELLER

JET PUMP
HOUSING NUTS

VENTURI
SCREWS

NOZZLE
SCREWS

JET PUMP
HOUSING COVER
SCREWS

2532201-Book Page 168 Thursday, August 1, 1996 8:17 AM

44 (32)

25 (18)

20 (15)

20 (15)

8 (6)

1988
7SP
(5801)

168

REAR STEERING
SUPPORT

a
a

20 (15)
10 (7)
N.A.
15 (11)

BALL JOINT
BOLT

FRONT STEERING
SUPPORT

STEERING STEM
ARM BOLT(S)

RIDE SHOE
SCREWS

HANDLEBAR
CLAMP BOLTS

INLET GRATE
SCREWS

2532201-Book Page 169 Thursday, August 1, 1996 8:17 AM

26 (19)
26 (19)
8 (6)

169

2532201-Book Page 170 Thursday, August 1, 1996 8:17 AM

170

2532201-Book Page 171 Thursday, August 1, 1996 8:17 AM

SECTION CONTENTS

MISCELLANEOUS

SI METRIC INFORMATION CHART . . . . . . . . . . . . . . . . . . . . . . . . .

PAGE
172

CONVERSION FACTORS. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

173

TAP DRILL SIZE (IMPERIAL) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

174

TAP DRILL SIZE (METRIC). . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

175

DRILL DIAMETER DECIMAL EQUIVALENTS . . . . . . . . . . . . . . . . . .

176

SERVICE PUBLICATION REPORT . . . . . . . . . . . . . . . . . . . . . . . . . . .

179

171

2532201-Book Page 172 Thursday, August 1, 1996 8:17 AM

SI METRIC INFORMATION CHART

BASE UNITS
DESCRIPTION

UNIT

length

meter

SYMBOL
m

mass

kilogram

kg

force

Newton

liquid

litre

temperature

celsius

pressure

kilopascal

kPa

torque

Newton meter

Nm

speed

kilometer per hour

km / h

PREFIXES

172

PREFIX

SYMBOL

MEANING

VALUE
1,000

kilo

one thousand

centi

one hundredth

0.01

milli

one thousandth

0.001

micro

one millionth

0.000001

2532201-Book Page 173 Thursday, August 1, 1996 8:17 AM

CONVERSION FACTORS

TO CONVERT

TO

MULTIPLY BY*

in

mm

25.40

in

cm

2.54

ft

0.30

miles

km

1.61

MPH

km / h

1.61

in2

cm2

6.45

in3

cm3

16.39

oz imp.

oz U.S.

0.96

oz imp.

mL

28.41

oz U.S.

mL

29.57

gal imp.

gal U.S.

1.20

gal imp.

4.55

gal U.S.

3.79

oz

28.35

lb

kg

0.45

lbf

4.45

lbfin

Nm

0.11

lbfft

Nm

1.36
12.00

lbfft

lbfin

lbf / in2

kPa

6.89

Fahrenheit

Celsius

(F 32) 1.8

Celsius

Fahrenheit

(C x 1.8) + 32

TO OBTAIN THE INVERSE SEQUENCE, DIVIDE BY THE GIVEN

FACTOR.
EX: TO CONVERT mm to in, divide by 25.4

CONVERSION FACTORS ARE ROUNDED OFF TO 2 DECIMALS FOR

EASIER USE.

173

2532201-Book Page 174 Thursday, August 1, 1996 8:17 AM

TAP DRILL SIZE (IMPERIAL)

TAP SIZE NO.

174

TPI

TAP DRILL

80 NF

3/64

64 NC
72 NF

53
53

56 NC
64 NF

50
50

48 NC
56 NF

47
45

36 NS
40 NC
48 NF

44
43
42

40 NC
44 NF

38
37

32 NC
40 NF

36
33

32 NC
36 NF

29
29

10

24 NC
32 NF

25
21

12

24 NC
28 NF

16
14

1/4

20 NC
28 NF

7
3

5/16

18 NC
24 NF

F
I

3/8

16 NC
24 NF

5/16
Q

7/16

14 NC
20 NF

U
25/64

1/2

13 NC
20 NF

27/64
29/64

9/16

12 NC
18 NF

31/64
33/64

5/8

11 NC
18 NF

17/32
37/64

11/16

11 NC
16 NF

19/32
5/8

3/4

10 NC
16 NF

21/32
11/16

7/8

9 NC
14 NF

49/64
13/16

2532201-Book Page 175 Thursday, August 1, 1996 8:17 AM

TAP DRILL SIZE (METRIC)

SIZE

PITCH

mm

mm

mm

DRILL
in

DRILL
in

M1.6

0.35

1.25

.049

3/64
1/16

M2

0.4

1.6

.063

M2.5

0.45

2.05

.081

46

M3

0.5

2.5

.098

40

M4

0.7

3.3

.130

30

M5

0.8

4.2

.165

19

M6

1.0

5.0

.197

M7

1.0

6.0

.236

15/64

M8

1.25

6.75

.266

17/64

M8

1.0

7.0

.276

M10

1.5

8.5

.335

M10

1.25

8.75

.344

11/32

M12

1.75

10.2

.402

M12

1.25

10.7

.421

27/64

M14

2.0

12.0

.472

15/32

M14

1.5

12.5

.492

31/64

M16

2.0

14.0

.551

35/64

M16

1.5

14.5

.571

9/16

M18

2.5

15.5

.610

39/64

M18

1.5

16.5

.650

41/64

M20

2.5

17.5

.689

11/16

M20

1.5

18.5

.728

23/32

M24

3.0

21.0

.827

53/64

M24

2.0

22.0

.866

55/64

175

2532201-Book Page 176 Thursday, August 1, 1996 8:17 AM

DRILL DIAMETER DECIMAL EQUIVALENTS

1
Based on 1 inch = 25.4 mm

DRILL
SIZE

mm

INCHES

DRILL
SIZE

mm

INCHES

80
79
1/64
78
77

76
75
74

73
72
71

70
69

68
1/32

67
66
65

64
63
62
61

60
59

0.10
0.20
0.25
0.30
0.34
0.37
0.40
0.41
0.46
0.50
0.51
0.53
0.57
0.60
0.61
0.64
0.66
0.70
0.71
0.74
0.75
0.79
0.79
0.80
0.81
0.84
0.89
0.90
0.91
0.94
0.97
0.99
1.00
1.02
1.04

.0039
.0079
.0098
.0118
.0135
.0145
.0156
.0160
.0180
.0197
.0200
.0210
.0225
.0236
.0240
.0250
.0260
.0276
.0280
.0292
.0295
.0310
.0313
.0315
.0320
.0330
.0350
.0354
.0360
.0370
.0380
.0390
.0394
.0400
.0410

58
57
56
3/64
55
54
53
1/16
52
51
50
49
48
5/64
47

46
45
44
43
42
3/32
41
40
39
38
37
36
7/64
35
34
33
32

31

1.07
1.09
1.18
1.19
1.32
1.40
1.51
1.59
1.61
1.70
1.78
1.85
1.93
1.98
1.99
2.00
2.06
2.08
2.18
2.26
2.37
2.38
2.44
2.49
2.53
2.58
2.64
2.71
2.78
2.79
2.82
2.87
2.95
3.00
3.05

.0420
.0430
.0465
.0469
.0520
.0550
.0595
.0625
.0635
.0670
.0700
.0730
.0760
.0781
.0785
.0787
.0810
.0820
.0860
.0890
.0935
.0938
.0960
.0980
.0995
.1015
.1040
.1065
.1094
.1100
.1110
.1130
.1160
.1181
.1200

176

2532201-Book Page 177 Thursday, August 1, 1996 8:17 AM

DRILL DIAMETER DECIMAL EQUIVALENTS

2
Based on 1 inch = 25.4 mm

DRILL
SIZE

mm

INCHES

DRILL
SIZE

mm

INCHES

1/8
30
29
28
9/64
27
26
25
24
23
5/32
22

21
20
19
18
11/64
17
16
15
14
13
3/16
12
11
10
9

8
7
13/64
6
5

3.18
3.26
3.45
3.57
3.57
3.66
3.73
3.80
3.86
3.91
3.97
3.99
4.00
4.04
4.09
4.22
4.31
4.37
4.39
4.50
4.57
4.62
4.70
4.76
4.80
4.85
4.91
4.98
5.00
5.05
5.11
5.16
5.18
5.22

.1250
.1285
.1360
.1405
.1406
.1440
.1470
.1495
.1520
.1540
.1562
.1570
.1575
.1590
.1610
.1660
.1695
.1719
.1730
.1770
.1800
.1820
.1850
.1875
.1890
.1910
.1935
.1960
.1968
.1990
.2010
.2031
.2040
.2055

4
3
7/32
2
1
A
15/64

B
C
D
1/4
E
F
G
17/64
H
I

J
K
9/32
L
M
19/64
N
5/16

O
P
21/64
Q
R
11/32

5.31
5.41
5.56
5.61
5.79
5.94
5.95
6.00
6.05
6.15
6.25
6.35
6.35
6.53
6.63
6.75
6.76
6.91
7.00
7.04
7.14
7.14
7.37
7.49
7.54
7.67
7.94
8.00
8.03
8.20
8.33
8.43
8.61
8.73

.2090
.2130
.2188
.2210
.2280
.2340
.2344
.2362
.2380
.2420
.2460
.2500
.2500
.2570
.2610
.2656
.2660
.2720
.2756
.2770
.2810
.2812
.2900
.2950
.2969
.3020
.3125
.3150
.3160
.3230
.3281
.3320
.3390
.3438

177

2532201-Book Page 178 Thursday, August 1, 1996 8:17 AM

DRILL DIAMETER DECIMAL EQUIVALENTS

3
Based on 1 inch = 25.4 mm

DRILL
SIZE

mm

INCHES

T
23/64
U
3/8
V
W
25/64

X
Y
13/32
Z
27/64

7/16
29/64
15/32

31/64
1/2

33/64
17/32
35/64

9/16
37/64

19/32
39/64
5/8

8.84
9.00
9.09
9.13
9.35
9.53
9.58
9.80
9.92
10.00
10.08
10.26
10.32
10.49
10.72
11.00
11.11
11.51
11.91
12.00
12.30
12.70
13.00
13.10
13.49
13.89
14.00
14.29
14.68
15.00
15.08
15.48
15.88
16.00

.3480
.3543
.3580
.3594
.3680
.3750
.3770
.3860
.3906
.3937
.3970
.4040
.4062
.4130
.4219
.4331
.4375
.4531
.4688
.4724
.4844
.5000
.5118
.5156
.5312
.5469
.5512
.5625
.5781
.5906
.5938
.6094
.6250
.6299

178

DRILL
SIZE

mm

INCHES

41/64
21/32

43/64
11/16
45/64

23/32
47/64

3/4
49/64
25/32

51/64
13/16

53/64
27/32
55/64

7/8
57/64

29/32
59/64
15/16

61/64
31/32

63/64
1"

16.27
16.67
17.00
17.07
17.46
17.86
18.00
18.26
18.65
19.00
19.05
19.45
19.84
20.00
20.24
20.64
21.00
21.03
21.43
21.83
22.00
22.23
22.62
23.00
23.02
23.42
23.81
24.00
24.21
24.61
25.00
25.00
25.40

.6406
.6562
.6693
.6719
.6875
.7031
.7087
.7188
.7344
.7480
.7500
.7656
.7812
.7874
.7969
.8125
.8268
.8281
.8438
.8594
.8661
.8750
.8906
.9055
.9062
.9219
.9375
.9449
.9531
.9688
.9842
.9844
1.0000

Bombardier

SERVICE PUBLICATION REPORT

Report of Error

Suggestion

Zip code / Postal code

City and state / Prov. _______________________________ Date _________________________________

Address __________________________________________________________________________________

Name ____________________________________________________________________________________

__________________________________________________________________________________________

__________________________________________________________________________________________

__________________________________________________________________________________________

Watercraft __________________________

Publication title and year ______________________ Page _____________________________________

2532201-Book Page 179 Thursday, August 1, 1996 8:17 AM

We would be delighted if you could communicate to Bombardier

any suggestion you may have concerning our publications.

HELPING US TO SERVE YOU BETTER

Valcourt (Qubec) J0E 2L0

Canada

Technical Publications

Bombardier Inc.

AFFIX
PROPER
POSTAGE

2532201-Book Page 180 Thursday, August 1, 1996 8:17 AM