Philips Mc20 SM

Micro System MC-20
all versions
TABLE OF CONTENTS
chapter chapter
Handling chip components and safety ............................. 1 - 1 POWER BOARD
Technical Specification & Service Tools.......................... 2 - 1 circuit diagram ....................................................... 9 - 1
Service Measurement .................................................. 2 - 2 layout diagram ....................................................... 9 - 1
Connections & Controls ................................................ 3 - 1
Instructions for use ................................................. 3 - 2 to 3 - 6 LED BOARD
Disassembly Diagram ................................................... 4 - 1 circuit diagram ...................................................... 10 - 1
CD Service Test Program ........................................ 4 - 2 to 4 - 3 layout diagram...................................................... 10 - 1
Block Diagram ............................................................. 5 - 1 RECORDER BOARD

Wiring Diagram ........................................................... 5 - 2 circuit diagram ................................................. 11 - 1, 11 - 3
layout diagram...................................................... 11 - 4
FRONT BOARD ajustment table ..................................................... 11 - 2
circuit diagram ....................................................... 6 - 1
layout diagram ....................................................... 6 - 2 CD MODULE
layout diagram ...................................................... 12 - 1
COMBI BOARD circuit diagram...................................................... 12 - 2
circuit diagram .................................................. 7 - 1 to 7 - 3
layout diagram ....................................................... 7 - 4 EXPLODED VIEWS DIAGRAM
cabinet ................................................................. 13 - 1
TUNER BOARD tape deck ...................................................... 13 - 2 to 13 - 3
circuit diagram ................................................... 8 - 1, 8 - 4
layout diagram .................................................. 8 - 2 to 8 - 3 Mechanical partslist ............................................... 13 - 2 to 13 - 3
Electrical partslist ............................................... 14 - 1 to 14 - 8
Safety regulations require that the set be restored to its original

condition and that parts which are identical with those specified
be used. CLASS 1
C
Copyright 1995 Philips Consumer Electroncis B.V. Eindhoven,The Netherlands LASER PRODUCT
All rights reserved. No part of this publication may be reproduced, stored in a retrieval
system or transmitted, in any form or by any means, electronic, mechanical, photocopying,
or otherwise without the prior permission of Philips.
Published by SS 0034 Service Audio Printed in The Netherlands Copyright reserved Subject to modification GB 3140 785 22420
PCS 104 581

1-1
HANDLING CHIP COMPONENTS
© WARNING ESD ñ WAARSCHUWING

All ICs and many other semiconductors are susceptible to Alle IC´s en vele andere halfgeleiders zijn gevoelig voor
electrostatic discharges (ESD). Careless handling during electrostatische ontladingen (ESD).
repair can reduce life drastically. Onzorgvuldig behandelen tijdens reparatie kan de levensduur
When repairing, make sure that you are connected with the drastisch doen vermindern. Zorg ervoor dat u tijdens reparatie
same potential as the mass of the set via a wristband with via een polsband met weerstand verbonden bent met hetzelfde
resistance. Keep components and tools at this potential. potentiaal als de massa van het apparaat.
Houd componenten en hulpmiddelen ook op ditzelfde potentiaal.
f ATTENTION i AVVERTIMENTO
Tous les IC et beaucoup dáutres semi-conducteurs sont d WARNUNG Tutti IC e parecchi semi-conduttori sono sensibili alle scariche
sensibles aux décharges statiques (ESD). Leur longévite Alle ICs und viele andere Halbleiter sind empfindlich statiche (ESD).
pourrait être considérablement écourtée par le fait quáucune gegenüber elektrostatischen Entladungen (ESD). La loro longevità potrebbe essere fortemente ridatta in caso di
précaution nést prise à leur manipulation. Unsorgfältige Behandlung im Reparaturfall kann die non osservazione della più grande cauzione alla loro
Lors de réparations, sássurer de bien être relié au même Lebensdauer drastisch reduzieren. manipolazione. Durante le riparationi occorre quindi essere
potentiel que la masse de láppareil et enfileer le bracelet Sorgen Sie dafür, daß Sie im Reparaturfall über ein Puls- collegato allo stesso potenziale che quello della massa
serti dúne résistance de sécurité. armband mit Widerstand mit dem Massepotential des delápparecchio tramite un braccialetto a resistenza.
Veiller à ce que les composants ainsi que les outils que lón Gerätes verbunden sind. Assicurarsi che i componenti e anche gli utensili con quali si
utilise soient également à ce potentiel. Halten Sie Bauteile und Hilfsmittel ebenfalls auf diesem lavora siano anche a questo potenziale.
Potential.
© SAFETY ñ
Safety regulations require that the set be restored to its Veiligheidsbepalingen vereisen, dat het apparaat in zijn
original condition and that parts which are identical with oorspronkeliijke toestand wordt teruggebracht en dat
those specified be used. onderdelen, identiek aan de gespecificeerde, worden toegepast.
Safety components are marked by the symbol De Veiligheidsonderdelen zijn aangeduid met het symbool
f i
Les normes de sécurité exigent que làppareil soit remis Le norme di sicurezza estigono che lápparecchio venga
à l`état dòrigine et que soient utilisées les pièces de rimesso nelle condizioni originali e che siano utilizzati i
rechange identiques à celles spécifiées. d pezzi di ricambiago identici a quelli specificati.
Les composants de sécurité sont marqués Bei jeder Reparatur sind die geltenden Sicherheitsvor- Componenty di sicurezza sono marcati con
schriften zu beachten. Der Originalzustand des Gerätes
darf nicht verändert werden. Für Reparaturen sind Original-
ersatzteile zu verwenden.
Sicherheitsbauteile sind durch das Symbol markiert.
CLASS 1 ©
© DANGER: Invisible laser radiation when open. After servicing and before returning the set to customer
AVOID DIRECT EXPOSURE TO BEAM.
LASER PRODUCT perform a leakage current measurement test from all
exposed metal parts to earth ground, to assure no
s Varning ! shock hazard exists.
Osynlig laserstrålning när apparaten är öppnad och The leakage current must not exceed 0.5mA.
spärren är urkopplad. Betrakta ej strålen.
∂ Advarsel ! ß Varoitus ! f
Usynlig laserstråling ved åbning når sikkerhedsafbrydere Avatussa laitteessa ja suojalukituksen ohitettaessa olet alttiina "Pour votre sécurite, ces documents doivent être utilisés par
er ude af funktion. Undgå udsaettelse for stråling. näkymättömälle laserisäteilylle. Älä katso säteeseen ! des spécialistes agréés, seuls habilités à réparer votre
appareil en panne".
PCS 104 437

2-1
TECHNICAL SPECIFICATIONS
GENERAL TUNER - AM SECTION
Mains voltage -/21/21M : 120 / 230 V Tuning range MW : 531 - 1602 kHz
-/22/25/30/33 : 230 V Tuning range LW : 153 - 279 kHz
Mains frequency -/22/25/30/33 : 50 Hz IF frequency : 450 kHz ± 1 kHz
-/21/21M : 50 / 60 Hz Sensitivity MW : £ 3.5 mV/m at 26dB S/N
Battery remote : 3 V (R6 x 2) LW : £ 4.2 mV/m
Power consumption normal : 60 W Selectivity MW : < 22 dB
Standby : 3W LW : < 35 dB
Dimension (W x H x D) : 223 x 140 x 247 mm IF rejection MW : < 64 dB
Weight : 5.6 Kg Spurious rejection ratio MW : < 58 dB
LW : < 51 dB
Image rejection ratio MW : < 40 dB
AMPLIFIER LW : < 47 dB
Output power mains : 2 x 8 W

Speaker impedance : 2 x 8 ohm AUDIO CASSETTE RECORDER
Frequency response : 100 Hz - 10 kHz (±4dB)
Frequency response : 80 - 12500 Hz
Wow & flutter : 0.4 % (DIN)
TUNER - FM SECTION Tape speed : 4.76 cm/s ± 2 %
Channel difference 1kHz : 0 dB
Tuning range : 87.5 - 108 MHz S/N ratio (unw.) Ferro : 47 dB
IF frequency : 10.7 MHz ± 0.02 MHz Chrome : 50 dB
Sensitivity : 16 dBf at 26dB S/N S/N ratio (wght.) Ferro : 52 dB
Selectivity 300kHz : 55 dB Chrome : 56 dB
IF suppression : 85 dB
Image suppression : 40 dB COMPACT DISC
Channel separation 1kHz : 28 dB
Frequency response : 20Hz – 20kHz within 1.5dB
S/N ratio (unw.) : > 85 dB
S/N ratio (A-wght.) : > 90 dB
THD+N 1 kHz : > 72 dB
Channel crosstalk : > 50 dB
Channel unbalance : < ±1 dB
SERVICE TOOLS
TORX T10 screwdriver with shaftlength 150mm.........................................4822 395 50423
TORX screwdriver set SBC 163...............................................................4822 295 50145
Audio signal disc SBC 429........ ..............................................................4822 397 30184

Playability test disc SBC 444...................................................................4822 397 30245
Test disc 5 (disc without errors ) +
Test disc 5A (disc with dropout errors, black spots and fingerprints)
SBC 426/426A.....................................................................4822 397 30096
Burn in test disc (65 min. 1kHz signal at -30 dB level without “pause”).....4822 397 30155
Universal test cassette Fe SBC 420 ........................................................4822 397 30071
AVAILABLE ESD PROTECTION EQUIPMENT

anti-static table mat large 1200x650x1.25mm 4822 466 10953
small 600x650x1.25mm 4822 466 10958
anti-static wristband 4822 395 10223
connection box (3 press stud connections, 1MΩ ) 4822 320 11307
extendible cable (2m, 2MΩ , to connect wristband to connection box) 4822 320 11305
connecting cable (3m, 2MΩ , to connect table mat to connection box) 4822 320 11306
earth cable (1MΩ , to connect any product to mat or to connection box) 4822 320 11308
KIT ESD3 (combining all 6 prior products - small table mat) 4822 310 10671
wristband tester 4822 344 13999
PCS 104 582

2-2
SERVICE MEASUREMENT
Tuner FW Bandpass
DUT 250Hz-15kHz LF Voltmeter
e.g. 7122 707 48001 e.g. PM2534
RF Generator
e.g. PM5326
Ri=50‰
S/N and distortion meter

e.g. Sound Technology ST1700B
Use a bandpass filter to eliminate hum (50Hz, 100Hz) and disturbance from the pilottone (19kHz, 38kHz).
Tuner AM (MW,LW)
Bandpass
250Hz-15kHz LF Voltmeter
DUT e.g. 7122 707 48001 e.g. PM2534
RF Generator
e.g. PM5326
S/N and distortion meter
e.g. Sound Technology ST1700B
Ri=50‰
Frame aerial
e.g. 7122 707 89001
To avoid atmospheric interference all AM-measurements have to be carried out in a Faraday«s cage.
Use a bandpass filter (or at least a high pass filter with 250kHz) to eliminate hum (50Hz, 100Hz).
CD RECORDER
Use Audio Signal Disc SBC429 4822 397 30184 Use Universal Test Cassette Fe SBC420 4822 397 30071
(replaces test disc 3)
DUT DUT
L LF Generator L
e.g. PM5110
R R
Ri=50‰
S/N and distortion meter S/N and distortion meter

e.g. Sound Technology ST1700B e.g. Sound Technology ST1700B
LEVEL METER LEVEL METER

e.g. Sennheiser UPM550 e.g. Sennheiser UPM550
with FF-filter with FF-filter
PCS 97 333
Controls
% Controls on the system and @ REPEAT/ REV MODE/ BAND
for CD ................. repeats a track/CD programme/
remote control
entire CD.
1 STANDBY ON y for Tape ............... selects tape reverse modes. 2 1
– switches the system to standby/on. for Tuner ............. selects waveband.
CD TAPE TUNER
– on the remote control only - switches the system # Mode Selection
to standby. STOP 9 ............ stops CD playback or erase a
2
TIMER AUX SLEEP
2 SELECT SOURCE CD programme. 5 *

DBB DSC INC. SURR
– selects the respective sound source for CD/ ................................. stops tape playback/recording.
TUNER/ TAPE /AUX.
0 &
PLAY•PAUSE ÉÅ MUTE SIDE NEWS/TA
– switches on the system. (É ) .................... starts CD/Tape playback. ^ Å

VOLUME #
3 Display .................................. (on the remote control only)
– shows the status of the system. switches Tape direction during
6 É 6
OPEN • CLOSE 4 PROGRAM playback. # í ë
$ for CD ................. programmes tracks and reviews (SIDE/Å ) ....... interrupts CD playback. #
Ç
the programme. .................................. (on the remote control only) # à á
for Tuner ............. programmes tuner stations switches Tape direction. 8
@ SHUFFLE
manually or automatically. PRESET 43
CONNECTIONS AND CONTROLS
REPEAT PROGRAM
4
5 TIMER ON•OFF ( ¡, ™ ) .............. selects a preset radio station.
– activates/deactivates or sets (on the system only) PREV ¡1 / NEXT 2™
the timer function. ( ¡, ™ ) ................ skips to the beginning of a
3 6 VOLUME ( -/+ ) current track/previous/
CD PROGRAM
– adjusts the volume level. subsequent track.
TIMER
1 STANDBY PROGRAM
PROGRAM 4
ON – on the system only - adjusts the hour and minutes ( à, á ) .......... fast searches back and forward
TIMER
for the clock/timer functions. within a track/CD.
SELECT ON • OFF
3-1
2 SOURCE 5 7 CLOCK/ RDS ................................. fast rewind/wind tape or during

for Clock ............ sets the clock function. playback, review and cue
DBB DSC INCREDIBLE SURR.
6 for Tuner ............. displays RDS information. passages.

0 for Tape ............... shows tape counter in recording TUNING à á
INTERACTIVE SOUND
VOLUME
mode. ( à, á ) .......... tunes to radio stations.
iR SENSOR STOP PRESET PLAY•PAUSE RDS RECORD ........ starts recording.
8 SHUFFLE/ SIDE A/B
! CLOCK 7 for CD ................. plays CD tracks in random order. $ OPEN•CLOSE
REPEAT TUNING
TUNING RECORD
RECORD TUNING
TUNING SHUFFLE for Tape ............... switches tape direction. – opens/closes the CD door.
REV MODE SIDE A/B % n
@ BAND 8 9 OPEN
PREV NEXT
– opens tape compartment. – connect headphones.
^ MUTE Notes for remote control:
# 0 INTERACTIVE SOUND controls:
– interrupts and resumes sound reproduction. – First select the source you wish to
OPEN 9 DBB .................... (Dynamic Bass Boost) enhances
& NEWS/TA control by pressing one of the source select
the bass.
– activates RDS news and Traffic Announcement keys on the remote control (e.g. CD ,
DSC ..................... (Digital Sound Control) selects
(not for all versions). TUNER, etc.).
sound characteristics: OPTIMAL/
* SLEEP – Then select the desired function (É, í,
ROCK/JAZZ/POP.
– activates/deactivates or selects the sleeper time. ë, etc.).
AUTO R E V E R S E INCREDIBLE SURROUND
................................. creates a super-enhanced stereo
effect.
! iR SENSOR
– infrared sensor for remote control.
PCS 104 583

Troubleshooting Basic Functions
WARNING Adjusting volume and sound
PCS 104 584

Do not open the system as there is a risk of electric shock! Under no circumstances
CD
TIMER PROGRAM
1 Turn the VOLUME control anti-clockwise to
should you try to repair the system yourself, as this will invalidate the warranty STANDBY PROGRAM
ON
decrease or clockwise to increase volume on the
TIMER
SELECT ON•OFF system (or press VOLUME -/+ on the
¶ If a fault occurs, first check the points listed below before taking the system for repair.
SOURCE
¶ If you are unable to remedy a problem by following these hints, consult your dealer or service centre. remote control).
‹ Display shows the volume level VOL and a
Symptom Remedy INTERACTIVE SOUND
number from 0-32.
VOLUME
CD PLAYER OPERATION iR SENSOR STOP PRESET PLAY•PAUSE RDS 2 Press the Interactive sound control, DSC on the
CLOCK
“NO DISC” is displayed. ¶ Check if the disc is inserted upside down. system or remote control once or more to
REPEAT TUNING RECORD TUNING SHUFFLE
select the desired sound effect: OPTIMAL (no
¶ Wait until the moisture condensation at the lens REV MODE SIDE A/B
BAND
PREV NEXT indication)/ ROCK ( ) / JAZZ ( )/

has cleared.
INSTRUCTIONS FOR USE
¶ Use a finalised CD-R(W). POP ( ) .

¶ Replace or clean the disc, see Maintenance. 3 Press DBB to switch bass enhancement on or
IMPORTANT:
Before you operate the system, complete off.
RADIO RECEPTION
the preparation procedures. ‹ Display shows: DBB if the DBB is activated.
Poor radio reception. ¶ The signal is too weak, adjust the antenna or
connect an external antenna for better 4 Press INCREDIBLE SURROUND (INC.
reception. Switching on SURR. on the remote control) to switch the
¶ Increase the distance from TV or VCR. There are 3 ways to switch the system on: surround sound effect on or off.
‹ Display shows: if activated.
¶ press 2 STANDBY ON on the system and
TAPE DECK OPERATION the last selected source switches on; Note:
Recording or playback cannot be ¶ Clean deck parts, see Maintenance. ¶ press SELECT SOURCE on the system and – The effect of INCREDIBLE SURROUND may
made. ¶ Use only NORMAL (IEC I) tape for recording. the last selected source switches on; vary with different types of music.
3-2
“CHECK TAPE” is displayed. ¶ Apply a piece of adhesive tape over the missing ¶ press CD, TUNER, TAPE or AUX on the 5 Press MUTE on the remote DBB DS
tab space. remote control. control to interrupt sound
reproduction instantly. MUTE SID
Tape deck door cannot open. ¶ Reconnect the AC power plug and switch on To switch the system to standby, press 2 Å
‹ Playback will continue
the system again. STANDBY ON once on the system (2 on VOLU
without sound and the display
the remote control). shows MUTE.
GENERAL
¶ If in recording mode, press STOP 9 (on the
Does not react when any buttons ¶ Press STANDBY ON to switch off the system. remote control 9 ) first. ¶ To activate sound reproduction you can:
is pressed. Remove the AC power plug from the wall ‹ The volume level, interactive sound settings, – press MUTE again;
outlet, then reconnect the power plug and – adjust the volume controls;
last selected source and tuner presets will be
switch on the system again. – change source.
retained in the player's memory.
No or poor sound. ¶ Adjust the volume.
¶ Disconnect the headphones.
Power-saving automatic standby
¶ Check that the speakers are connected
correctly. As a power-saving feature, the system
¶ Check if the stripped speaker wire is clamped. automatically switches to standby 15 minutes
after a tape or CD has reached the end and no
Reversed left and right sound. ¶ Check the speaker connections and location. control is operated.
Remote control does not function properly. ¶ Select the source (CD, TUNER, etc.)
before pressing the function button (É,í,ë,
etc.).
¶ Reduce the distance to the system.
¶ Insert the batteries with their polarities
(+/-signs) as indicated.
¶ Replace the batteries.
Timer is not working. ¶ Set the clock.
¶ Press TIMER ON•OFF to switch on the timer.
¶ If recording is in progress, stop recording.
Compact Disc Compact Disc
‹ The display freezes and the elapsed playing 1 To select your play mode, press the SHUFFLE Reviewing the programme
time flashes when playback is interrupted. or REPEAT button before or during playback In STOP mode, press and hold down
CD
PROGRAM until the display shows the desired function.
STANDBY PROGRAM PROGRAM on the system or remote control,
ON 6 To stop disc playback, press STOP 9.
TIMER
2 Press PLAY•PAUSE 2; (on the remote for a while until the display shows all your stored
SELECT ON • OFF Note: CD play will also stop when;
SOURCE track numbers in sequence.
control 2) to start playback if in the STOP
– the CD door is opened.
DBB DSC INCREDIBLE SURR. position.
– the disc has reached the end.
‹ If you have selected SHUFFLE, playback starts Erasing the programme
INTERACTIVE SOUND
– you select another source: TAPE,TUNER or AUX.
VOLUME
automatically. You can erase the programme by:
iR SENSOR STOP PRESET PLAY•PAUSE RDS
CLOCK 3 To return to normal playback, press the ¶ pressing STOP 9 once in the STOP mode;
Selecting a different track
respective SHUFFLE or REPEAT button until ¶ pressing STOP 9 twice during playback;
REV MODE SIDE A/B ¶ Press PREV ¡1 or NEXT 2™ on the system,
BAND the various SHUFFLE/ REPEAT modes are no
PREV NEXT
¶ opening the CD compartment;
(on the remote control ¡ or ™) once or longer displayed. ‹ PROGRAM disappears from the display.
repeatedly until the desired track number ¶ You can also press STOP 9 to cancel your play
appears in the display. mode.
IMPORTANT:
¶ If you have selected a track number shortly after
The lens of the CD player should never be
loading a disc or in the PAUSE position, you will
touched. Programming track numbers
need to press PLAY•PAUSE 2; (on the
remote control 2) to start playback. Programme in the STOP position to select and
X store your disc tracks in the desired sequence. If
you like, store any track more than once. Up to
Finding a passage within a track 20 tracks can be stored in the memory.
1 Press and hold down on PREV ¡1 or NEXT 1 Press PROGRAM on the system or remote
2™. control to enter the programming mode.
Playing a disc ‹ The disc is played at high speed and low ‹ A track number is shown and PROGRAM
This CD player plays Audio Discs including CD- volume. flashes.
3-3
Recordables and CD-Rewritables.

2 When you recognise the passage you want, 2 Use the PREV ¡1 or NEXT 2™ on the
¶ CD-ROM, CD-I, CDV, VCD, DVD or computer release PREV ¡1 or NEXT 2™. system, (on the remote control ¡ or ™) to
CDs, however, are not possible. ‹ Normal playback continues. select your desired track number.
Note: 3 Press PROGRAM to confirm the track number
1 Select CD source.
OPEN • CLOSE
– During a disc programme or if SHUFFLE/ to be stored.
2 Press OPEN•CLOSE on the top REPEAT active, searching is only possible within the ‹ The number of tracks programmed and total
of the system to open the CD same track. playing time of the programme is shown briefly,
compartment. then the selected track and PROG.
‹ OPEN is displayed when you
Different play modes: SHUFFLE 4 Repeat steps 2-3 to select and store all desired
open the CD compartment.
and REPEAT tracks.
3 Insert a disc with the printed side You can select and change the various play ‹ FULL is displayed if you attempt to
facing up and press down on OPEN•CLOSE modes before or during playback. The play programme more than 20 tracks.
to close the CD door. modes can also be combined with
‹ READ is displayed as the CD player scans the PROGRAMME.
5 To start playback of your disc programme, press
contents of a disc, and then the total number of PLAY•PAUSE 2; (on the remote control 2).
tracks and playing time are shown. SHUFFLE ......... tracks of the entire disc/
programme are played in
4 Press PLAY•PAUSE 2; (on the remote random order
control 2) to start playback. SHUFFLE and REPEAT ALL…to repeat the
‹ Current track number and elapsed playing entire disc/ programme
time of the track are displayed during disc continuously in random order
playback. REPEAT ALL ... repeats the entire disc/
5 To interrupt playback press PLAY•PAUSE 2; programme
(on the remote control SIDE/;). Press REPEAT ............ plays the current track
PLAY•PAUSE 2; (on the remote control 2) continuously
again to resume play.
PCS 104 585

Tuner Tuner
2 Press PROGRAM on the system or remote Note:
RDS News and Traffic
– If you press RDS and the RDS signal is not
PCS 104 586

control for more than 2 seconds to activate
Announcement (TA)
TUNER PROGRAM
TIMER
programming. available NO RDS is displayed.
STANDBY PROGRAM
ON You may set up the tuner in such a way that
‹ AUTO is displayed and available stations are
SELECT
TIMER
listening to CD or tape is interrupted by the
ON•OFF programmed in order of waveband reception
SOURCE EON NEWS of a RDS station. This only works if the
strength: FM followed by MW and LW. The last Enhanced Other Network allows you to
DBB DSC INCREDIBLE SURR. RDS station broadcasts a NEWS signal while
preset automatically stored will then be played. search for an RDS station offering a certain sending the news.
INTERACTIVE SOUND programme type. If EON is available, is
VOLUME 1 Tune to the desired RDS station.
iR SENSOR STOP PRESET PLAY•PAUSE RDS
Manual programming shown.
CLOCK
1 Tune to your desired station (see Tuning to radio 2 Press NEWS/TA once or SC INC. SURR
REV MODE
stations). more on the remote control to
SIDE A/B
BAND
Searching programme type
PREV NEXT select the NEWS option. DE NEWS/TA
2 Press PROGRAM on the system or remote (PTY)
‹ NEWS ON, TA ON or OFF is Å

control to activate programming. PTY helps you find a desired programme type. UME
displayed briefly.
‹ PROGRAM flashes in the display. To enable PTY, first programme RDS stations
Tuning to radio stations ‹ NEWS is displayed if you have
3 Press PRESET 4 or 3 (¡ or ™ on the remote into the tuner memory (see Programming radio
activated the NEWS or TA option. Changing
1 Select TUNER source. control) to allocate a number from 1 to 40 to stations)
listening source will not disarm the function.
‹ TUNER is displayed briefly. this station. 1 While receiving an RDS station, press RDS
briefly until the programme type is displayed. Notes:
2 Press BAND once or more to select your 4 Press PROGRAM again to confirm the setting. – To avoid unwanted recordings, the NEWS
waveband. ‹ PROGRAM disappears, the preset number and 2 Press PRESET 4 or 3 ( ¡ or ™ on the remote announcement does not work while recording a
3 Press down on TUNING à or á and release the frequency of the preset station are shown. control) until the desired programme type is cassette.
button. displayed. – When you receive RDS news or traffic
5 Repeat the above four steps to store other
‹ The radio automatically tunes to a station stations. 3 Press and hold down on TUNING à or á announcements during CD playback, playback will
with sufficient reception. Display indication during ( à or á on the remote control) to start pause and you will be able to hear the news/TA.
3-4
automatic tuning: SEARCH. ¶ You can override a preset station by storing Playback resumes after the broadcast has finished.
searching.
‹ If a FM station is received in stereo, STEREO is another frequency in its place. In tape mode, the tape continues playing but you
‹ The radio tunes to a RDS station
shown. broadcasting this programme type. If the will hear the news/TA only until the broadcast has
Tuning to preset stations programme type is not available TYPE NOT finished.
4 Repeat step 3 if necessary until you find the
FOUND is displayed. – If you are using the RDS NEWS announcement
desired station. ¶ Press PRESET 4 or 3 ( ¡ or ™ on the
with an EON station, the whole network is
remote control) until the desired preset station
¶ To tune to a weak station, press TUNING à RDS Programme types searched for the respective news.
is displayed.
or á briefly and repeatedly until you have NO TYPE .......... No RDS programme type
found optimal reception. NEWS .................... News services Disarming RDS News and Traffic
RDS (some versions only) AFFAIRS .......... Politics and current affairs Announcement
Programming radio stations Radio Data System is a service that allows There are a number of ways to disarm the news
INFO .................... Special information programmes
FM stations to show additional information. If feature:
You can store up to a total of 40 radio stations SPORT ................ Sports
in the memory. you are receiving a RDS station, and the EDUCATE .......... Education and advanced training ¶ Press NEWS/TA on the remote control during
station name are displayed. DRAMA ................ Radio plays and literature reception of the news option.
Automatic programming When automatic programming is used, RDS ¶ Press standby on the system or remote control.
CULTURE .......... Culture, religion and society
Automatic programming will start with a chosen stations will be programmed first. ¶ Tune to a non-RDS-station.
SCIENCE .......... Science
preset number. From this preset number
Scrolling through different RDS VARIED ............. Entertainment programmes
upwards, former programmed radio stations will
information POP M ................. Pop music
be overridden. The system will only programme
¶ Press RDS briefly and repeatedly to scroll ROCK M .............. Rock music
stations which are not in the memory already.
through the following information (if available): MOR M ................. Light music
1 Press PRESET 4 or 3 ( ¡ or ™ on the – Station name LIGHT M .......... Light classical music
remote control) to select the preset number CLASSICS ...... Classical music
– Programme type such as NEWS, SPORT,
where programming should start. OTHER M .......... Special music programmes
POP M ...
Note: – Radio text messages
– If no preset number is selected, default is preset – Frequency
(1) and all your presets will be overridden.
Tape Recorder Tape Recorder
Switching tape sides Synchro Start CD recording Recording Timer
The tape side can be switched manually or 1 Select CD source. To record from the radio, you will need to use a
TIMER PROGRAM
STANDBY SIDE A PROGRAM automatically before or during tape playback.
SIDE B
ON
preset radio station and to set a start (ON) and
TIMER
2 Insert a disc and if desired, programme track finish (OFF) time.
TIMER
SELECT ON • OFF
ON • OFF
¶ Press SIDE A/B (SIDE/; or during playback
SOURCE numbers.
only 2 on the remote control). 1 Insert a suitable tape into the deck.
‹ The display shows SIDE A or SIDE B and the 3 Press OPEN to open the tape door. ‹ If desired, select tape reverse mode option.
tape counter resets to 000.
INTERACTIVE SOUND 4 Insert a suitable tape into the deck and close the 2 Select the preset radio station to record from.
VOLUME
iR SENSOR STOP PRESET PLAY•PAUSE
tape door.
RDS
CLOCK
Reverse mode options 3 Press TIMER ON•OFF for more than 2
REPEAT TUNING RECORD TUNING
¶ Press REV MODE once or more to select your 5 Press RECORD to start recording. seconds.
SHUFFLE
REV MODE
BAND
SIDE A/B option; ‹ COPY or RECORD is displayed briefly and ‹ TIMER flashes and a source is displayed.
PREV NEXT
å : playback stops at the end of the tape. RECORD is shown during recording.
‹ Playing of the disc programme starts
4 Press SELECT SOURCE repeatedly, or turn
∂ : both sides are played once. VOLUME clockwise until REC TUN source is
∫ : both sides are played repeatedly, up automatically from the beginning of the disc/
displayed.
Tape playback to 5 times each side. after 7 seconds. It is not necessary to start the
CD player separately. 5 Press TIMER ON•OFF to confirm the source.
1 Select TAPE source. ¶ If you wish, press CLOCK once to monitor the ‹ SET ON TIME is displayed, TIMER and the
‹ The display shows TAPE briefly. The tape General Information on counter display. clock digits for the hours flash.
counter TAPE 000 display with the SIDE A or Recording
SIDE B and reverse mode status are then shown 6 To stop recording, press STOP 9. 6 Turn VOLUME to set the hours: clockwise for
¶ Recording is permissible insofar as copyright or hours up; anti-clockwise for hours down.
during tape mode.
other rights of third parties are not infringed.
2 Press OPEN to open the tape door. ¶ For recording, use only NORMAL (IEC type I) Recording from the Radio 7 Press TIMER ON•OFF again.
cassette on which the tabs have not yet been 1 Tune to the desired radio station (see Tuning to ‹ The clock digits for the minutes flash.
3 Insert a recorded tape and close the tape door.
broken. This deck is not suited for recording on radio stations). 8 Turn VOLUME to set the minutes: clockwise for
¶ Load the tape with the open side downward and
METAL (IEC IV) type cassettes. minutes up; anti-clockwise for minutes down.
3-5
the full spool to the left. 2 Press OPEN to open the tape door.
¶ The best recording level is set automatically.
4 Press PLAY•PAUSE 2; (on the remote Altering the VOLUME, INCREDIBLE 3 Insert a suitable tape into the deck and close the 9 Press TIMER ON•OFF to confirm the ON
control 2) to start playback. SURROUND, DBB or INTERACTIVE SOUND tape door. start time.
controls will not affect the recording in progress. ‹ SET OFF TIME is displayed, TIMER and the
5 By pressing à or á on the remote control, fast 4 Press RECORD to start recording. clock digits for the hours flash.
winding of tape is possible in both directions. ¶ At the very beginning and end of the tape, no ‹ RECORD is displayed briefly and RECORD is
¶ To review and cue at low volume, press ¡1 or recording will take place during the 7 seconds shown during recording. 10 Repeat steps 6-8 to set the finish time.
2™ on the system. when the leader tape passes the recorder heads. ¶ If you wish, press CLOCK once to monitor the
¶ To protect a tape from accidental erasure, have
11 Press TIMER ON•OFF to confirm the timer
¶ During fast winding or review/cue you can counter display. settings.
monitor the tape message with the tape counter. the tape in front of you and break out the left
5 To stop recording, press STOP 9. ‹ TIMER is shown and the recording timer is
Release the fast wind/cue control at your desired tab. Recording on this side is no longer possible.
now set.
passage. If, however, you wish to record over this side
again, cover the tabs with a piece of adhesive Recording from AUX
6 To stop the tape, press STOP 9 on the system tape.
or remote control. 1 Select AUX source.
¶ To reset the tape counter, press STOP 9 again. 2 If necessary, prepare the additional appliance for
Note: recording.
– The sound source cannot be changed while 3 Press RECORD to start recording.
recording a tape. ‹ RECORD is displayed briefly and RECORD is
shown during recording.
¶ If you wish, press CLOCK once to monitor the
counter display.
4 To stop recording, press STOP 9.
PCS 104 587

Clock/Timer Clock/Timer
Setting TIMER Activating and deactivating ¶ To deactivate, press SLEEP on the remote
control once or more until SLEEP OFF is
PCS 104 588

¶ The system can be used as an alarm clock, SLEEP
CD PROGRAM
shown, or press STANDBY ON on the system
TIMER
STANDBY PROGRAM
ON whereby the CD, TUNER or TAPE is switched on The sleep timer enables the system to switch off or remote control.
TIMER at a set time. The clock time needs to be set first by itself after a set period of time. The clock time
SELECT ON•OFF
‹ SLEEP OFF scrolls across the display.
SOURCE
before the timer can be used. needs to be set first before the sleep timer can
DBB DSC INCREDIBLE SURR. be used.
¶ You can also use it to record a favourite tuner
programme at a set period (REC TUN, see TAPE ¶ Press SLEEP on the remote APE TUNER
INTERACTIVE SOUND
VOLUME RECORDER) control once or more.

iR SENSOR STOP PRESET PLAY•PAUSE RDS UX SLEEP
CLOCK
¶ During setting, if no button is pressed within 90 ‹ Display shows SLEEP and
seconds, the system will exit timer setting mode
one of the sleep time options SC INC. SURR
REV MODE SIDE A/B automatically.
BAND
in sequence: 60, 45, 30,15,
PREV NEXT
1 In any mode, press TIMER ON•OFF for more SLEEP OFF, 60... if you have
than 2 seconds. selected a time. Once SLEEP is activated, SLEEP

ON scrolls across the display at repeated
Setting the clock 2 Turn VOLUME clockwise to select sound intervals.
There are two possible methods for setting the source.
clock: manually or automatically by using RDS. ‹ Display sequence shows CD, TUNER, TAPE or
REC TUNER.
Automatic clock setting (RDS versions 3 Press TIMER ON•OFF to confirm your
only) desired mode.
1 Tune to a RDS station (see TUNER). ‹ The selected source CD or TUNER
is shown. Display sequence scrolls SET ON
2 Press CLOCK for more than 2 seconds. TIME and TIMER flashes. The clock digits for the
‹ SEARCH RDS TIME is displayed for a hours flash. Maintenance
maximum of 90 seconds; the time is then
3-6
displayed. 4 Turn VOLUME to set the hours: clockwise for

‹ NO RDS TIME is displayed if no time signal hours up; anti-clockwise for hours down. Cleaning the Cabinet Cleaning the Heads and the Tape Paths
has been received and you will have to set the ¶ Use a soft cloth slightly moistened with a mild ¶ To ensure good recording and playback quality,
5 Press TIMER ON•OFF again. detergent solution. Do not use a solution clean the heads A, the capstan(s) B, and
clock manually. ‹ The clock digits for the minutes flash. containing alcohol, spirits, ammonia or abrasives. pressure roller(s) C after every 50 hours of
Manual clock setting 6 Turn VOLUME to set the minutes: clockwise for tape operation.
minutes up; anti-clockwise for minutes down. Cleaning Discs ¶ Use a cotton swab slightly moistened with
1 In standby, press CLOCK. ¶ When a disc becomes dirty, cleaning fluid or alcohol.
‹ The clock digits for the hours flash. 7 Press TIMER ON•OFF to confirm the time. clean it with a cleaning cloth. ¶ You can also clean the heads by playing a
‹ The timer is now set and activated.
2 Turn VOLUME to set the hours: clockwise for Wipe the disc from the centre cleaning tape once.
hours up; anti-clockwise for hours down. out.
Activating and deactivating ¶ Do not use solvents such as
3 Press CLOCK again. TIMER benzine, thinner, commercially
‹ The clock digits for the minutes flash.
¶ In standby or during playback, press TIMER available cleaners, or antistatic
4 Turn VOLUME to set the minutes: clockwise for ON•OFF on the system once (TIMER on the spray intended for analogue records.
minutes up; anti-clockwise for minutes down. remote control).
Cleaning the disc lens A A B C
5 Press CLOCK to confirm the time. ‹ Display shows TIMER if activated, and
disappears if deactivated. ¶ After prolonged use, dirt or dust may
accumulate at the disc lens. To ensure good Demagnetising the heads
playback quality, clean the disc lens with Philips ¶ Use a demagnetising tape available at your
CD Lens Cleaner or any commercially available dealer.
cleaner. Follow the instructions supplied with
cleaner.
4-1 4-1
DISASSEMBLY DIAGRAM
A. To remove Cabinet Rear

B. To remove CD Tray
C. To remove Tuner Board Bracket
D. To remove Combi Board Bracket
E. To remove Bottom Plate
F. To remove Tape Deck
G. To remove Front Board
PCS 104 191

4-2 4-2
SERVICE TESTPROGRAM
To enter Service * Door switch is ignored Æ CD door can be opened.

Testprogram hold
Program & Shuffle buttons * In CD- and Tuner tests the sound settings Volume up/down,
depressed while DSC, IS and DBB function as in normal mode,
plugging mainscord in. but flags will not be indicated on the display in all steps.
Display shows
version number S stands for Service mode
of the µP - software. Slide servo, Radial servo, Focus servo, Disc motor
S 84 and Laser are switched off.
Mute is switched on via decoder IC.
DISPLAY TEST CD SERVO TEST

FORMAT EEPROM TUNER TEST TAPE TEST
N DBB button N PLAY button STOP button pressed in any step returns
pressed? pressed? to begin of Service Testprogram.
RDS button N PROG button N RECORD button N
pressed? pressed? pressed?
Y Y
Display shows all Y Y Y

segments and flags Display shows
for checking open circuits.
see figure 1 CD99 Display shows Display shows version Display shows
IS - LED is switched on. of tuner board as long as
SLIDE MOTOR test DISC MOTOR test EPF any key will be pressed.
TAPE
for 2s. Solenoids of the deck
EEPROM is cleared and e.g. EUR are activated for 2s and
N DBB button N PLAY button NEXT button N PREV. button N SHUFFLE button N PROG button N default values are stored. deactivated for 3s.
pressed? pressed? pressed? pressed? pressed? pressed? Tuner is normal working
except for the PROGRAM
Y Y Y Y Y Y button.
FOCUS search This test should be done at the
Display shows figure 2. Display shows Display shows: Display shows:
All alternate pins (2, 4, ..)
end of the production process
FOC ERR Slide moves Slide moves N
of the display are activated
outside as inside as
CW CCW so that every set is customised STOP button
for checking shortcircuits. objective moves up&down Disc motor turns before leaving factory. pressed?
long as button long as button Disc motor turns
IS - LED is switched off. disc motor for 300ms "on" clockwise
is held is held counter clockwise
depressed. depressed. as long as button as long as button Y
is held depressed. is held depressed.
POWER N
N STOP button N switched off?
FOCUS found? Switch all actions off
pressed?
Y Y Y
Display shows
Exit Service Testprogram
FOC OK
disc motor turns.
DBB CD TIMER TUNER

EON SIDE A PROGRAM SHUFFLE FM STEREO
NEWS SIDE B RECORD REPEAT ALL MWLWAM
N PLAY button
pressed?
fig. 1 Display shows
DISK OK
STEREO CD ERROR CODES

AM PLAY button N
pressed? Error number Error description Error type
Y E1000 Focus error

Triggered when the focus is lost during playing the CD. W
Display shows
fig. 2 E1001 Radial error
RDL Triggered when the radial servo is not on track for a certain time during playing the CD. W
release mute
E1002 Slide-in error
The sledge did not reach its inner position (innerswitch is closed) before approximately 6 W
seconds have pressed by - innerswitch or sledgemotor problem.
N NEXT button PREV button N
pressed? pressed?
E1003 Slide-out error
The sledge did not come out of its inner position (innerswitch is open) before W
Y Y approximately 300ms have passed by - innerswitch or sledgemotor problem.
jumps in steps of jumps in steps of E1005 Jump error

16 tracks backwards Triggered when the jump destination could not be found within a certain time. W
16 tracks forward
E1006 Subcode error W

No valid subcode for a certain time during play.
TUNER VERSIONS
E1007 PLL error
The Phase-Lock-Loop could not lock within a certain time. W
EUR USA OSE
E1008 Turntable motor error
EUROPE USA OVERSEAS Generated when the CD could not reach 75% of speed during start-up within a certain W
REGION FM/MW FM/MW FM/MW
time. Discmotor problem.
& 1)Grid switchable
SET VERSIONS 100/10kHz - 50/9kHz
/22/25 /37 /21/21M/30 E1020 Focus search error
The focus point has not been found within a certain time. F
table 2
table 1
1) To toggle frequency grid press SHUFFLE button for more than 5s in normal tuner mode (not in service testmode).
Error type: W = Warning Æ set continues operation, message remains on the display until next error occurs
or any key is pressed.
Display will show either GRID 9 or GRID 10 for 2 s.
F = Fatal Error Æ set stops operation, message remains on the display.
PCS 104 192

4-3 4-3
Abbreviations and Pin-description of CD Ics Abbreviations and Pin-description of CD Ics
SERVO PROCESSOR SAA7325H SERVO PROCESSOR SAA7325H

SYMBOL PIN DESCRIPTION SYMBOL PIN DESCRIPTION
HFREF 1 comparator common mode input RAB 41 microcontroller interface R/W and load control line input (4-wire bus mode)
HFIN 2 comparator signal input SILD 42 microcontroller interface R/W and load control line input (4-wire bus mode)
ISLICE 3 current feedback output from data slicer STATUS 43 servo interrupt request line/decoder status register output (open-drain)
VSSA1 4(1) analog ground 1 TEST3 44 test control input 3; this pin should be tied LOW
VDDA1 5(1) analog supply voltage 1 RCK 45 subcode clock input
Iref 6 reference current output pin SUB 46 P-to-W subcode bits output (3-state)
VRIN 7 reference voltage for servo ADC's SFSY 47 subcode frame sync output (3-state)
D1 8 unipolar current input (central diode signal input) SBSY 48 subcode block sync output (3-state)
D2 9 unipolar current input (central diode signal input) CL11/4 49 11.2896 MHz or 4.2336 MHz (for microcontroller) clock output
D3 10 unipolar current input (central diode signal input) VSSD2 50(1) digital ground 3
D4 11 unipolar current input (central diode signal input) DOBM 51 bi-phase mark output (externally buffered; 3-state)
R1 12 unipolar current input (satellite diode signal input) VDDD1(P) 52(1) digital supply voltage 2 for periphery
R2 13 unipolar current input (satellite diode signal input) CFLG 53 correction flag output (open-drain)
VSSA2 14(1) analog ground 2 RA 54 radial actuator output
CROUT 15 crystal/resonator output FO 55 focus actuator output
CRIN 16 crystal/resonator input SL 56 sledge control output
VDDA2 17(1) analog supply voltage 2 VDDD2(C) 57(1) digital supply voltage 3 for core
LN 18 DAC left channel differential output - negative VSSD3 58(1) digital ground 4
LP 19 DAC left channel differential output - positive MOTO1 59 motor output 1; versatile (3-state)
Vneg 20 DAC negative reference input MOTO2 60 motor output 2; versatile (3-state)
Vpos 21 DAC positive reference input V4 61 versatile output pin 4
RN 22 DAC right channel differential output - negative V5 62 versatile output pin 5
RP 23 DAC right channel differential output - positive V1 63 versatile intput pin 1
SELPLL 24 selects whether internal clock multiplier PLL is used LDON 64 laser drive on output (open-drain)
TEST1 25 test control input 1; this pin should be tied LOW
CL16 26 16.9344 MHz system clock output Note : All supply pins must be connected to the same external power supply voltage.
DATA 27 serial d4(1)ata output (3-state)
WCLK 28 word clock output (3-state)
SCLK 29 serial bit clock output (3-state)
EF 30 C2 error flag output (3-state)
TEST2 31 test control input 2; this pin should be tied LOW
KILL 32 kill output (programmable; open-drain)
VSSD1 33(1) digital ground 2
V2/V3 34 versatile I/O: input versatile pin 2 or output versatile pin 3 (open-drain)
WCLI 35 word clock iutput (for data loopback to DAC)
SDI 36 serial data input (for data loopback to DAC)
SCLI 37 serial bit clock input (for data loopback to DAC)
RESET 38 power-on reset input (active LOW)
SDA 39 microcontroller interface data I/O line (open-drain output)
SCL 40 microcontroller interface clock line input
PCS 99 458
5-1 5-1
BLOCK DIAGRAM
+B
AUX
+12V_S (MC10) +5V6_S A0/A1

+12.5V (MC20) TAPE_REC
From +5V6_S
+5V6_S Processor MC10
+5V6_S
+12.5V
V
PWM (MC20)
From BUFFER POWER AMP
Processor ECO6 DIGITAL
VOLUME
ELECTRONIC 8 OHM
V
TUNER MODULE 4 W (MC10)
SOURCE CONTROL DCC 8 W (MC20)
SELECTOR (Rock, Pop Jazz, I.S.)
V
R
CONTROL
V
LINES
+MOT (MC10) +5V +5V6S (MC10)

+12.5V (MC20) (MC20) +12V_S (MC20) STAND_BY
+12.5V
TAPE_REC
From
Processor MTF (MC10)
ETF (MC20) -8V2 To TAPE To CD To Tuner +5.6V +5V6 -8V2
TAPE MODULE (MC20)
Backlight
SHIFT ON / OFF -8V2

+CD
V
REGISTER Stabilizer
MICRO (MC20)
+MOT +CD
LCD
PROCESSER
ON / OFF +B
V
V
+12.5V +A
V
D
From ~
CD99 +12V_S +12.5V
Processor RESET
CD MODULE Stabilizer
+ -
V
~
MC20
D +5V6_S
+5V6_S +5V6
MPX RDS +5V6 +MOT

From Tuner DECODER Stabilizer
V V
D ON / OFF
FOR /22 ONLY
ON / OFF
V
PCS 104 564

5-2 5-2
WIRING DIAGRAM
PCS 104 193

6-1 6-1
FRONT BOARD - CIRCUIT DIAGRAM
0001 F15 1406 I8 1413 I5 1425 A5 2406 E5 2413 F6 2420 I11 2427 I2 2434 B13 2441 D13 2448 G13 3403 E5 3410 H4 3417 H10 3424 I10 3431 I7 3438 I12 3445 G1 3452 A13 3459 C13 3466 F9 3473 F9 3480 F14 3487 G14 3494 D11 4401 I9 6401 B14 9400 F1 T406 C14 T413 D14 T426 F14 T441 A11 T448 H5
1400 I11 1407 I8 1414 I4 2400 B11 2407 F5 2414 G6 2421 I7 2428 I3 2435 D12 2442 F12 2449 H13 3404 E5 3411 H5 3418 D11 3425 I9 3432 I6 3439 F9 3446 G1 3453 E11 3460 F8 3467 C13 3474 E14 3481 E11 3488 D11 3495 G13 5400 A10 7400 D8 9401 A11 T407 C14 T414 D14 T431 G14 T442 B11 T449 H10
1401 I10 1408 I7 1415 I12 2401 B11 2408 F4 2415 F6 2422 I12 2429 I3 2436 D12 2443 F13 2450 H13 3405 F4 3412 H5 3419 D11 3426 I9 3433 I6 3440 F7 3447 A14 3454 A14 3461 C14 3468 F9 3475 D11 3482 F14 3489 G14 3496 G13 5401 C11 7402 F5 T401 B14 T408 C14 T421 E14 T432 G14 T443 F6 T451 A10
1402 I10 1409 I6 1416 B15 2402 B9 2409 F4 2416 F6 2423 I12 2430 A14 2437 D13 2444 F13 2451 H13 3406 F4 3413 F7 3420 I11 3427 I8 3434 I5 3441 F7 3448 A14 3455 F8 3462 F9 3469 C14 3476 E14 3483 E13 3490 C11 3497 F8 5402 F5 7403 G6 T402 B14 T409 C14 T422 E14 T433 G14 T444 F6 T452 A10
1403 I9 1410 I6 1417 D15 2403 B10 2410 F5 2417 H4 2424 F1 2431 B12 2438 D13 2445 F13 3400 A11 3407 F5 3414 F9 3421 I11 3428 I8 3435 I5 3442 E3 3449 A14 3456 B13 3463 C13 3470 F7 3477 E11 3484 E11 3491 G13 3498 G8 5403 F6 7404 H5 T403 B14 T410 C14 T423 E14 T434 G14 T445 G4 T453 H4
1404 I9 1411 I6 1418 E15 2404 C11 2411 F5 2418 H5 2425 G1 2432 B13 2439 D13 2446 F13 3401 A10 3408 G6 3415 H8 3422 I11 3429 I7 3436 I5 3443 F3 3450 F8 3457 A13 3464 F9 3471 D14 3478 E14 3485 F14 3492 D11 3499 G3 5404 G1 7405 H9 T404 B14 T411 C14 T424 F14 T435 G14 T446 G4
1405 I8 1412 I5 1420 G15 2405 C11 2412 F6 2419 H9 2426 G1 2433 B13 2440 D13 2447 G12 3402 C11 3409 F7 3416 H9 3423 I10 3430 I7 3437 I12 3444 F1 3451 A13 3458 F8 3465 C14 3472 D13 3479 E11 3486 D11 3493 G14 4400 H9 6400 A11 7406 F2 T405 C14 T412 D14 T425 F14 T436 H14 T447 G4
1 2 3 4 5 6 7 8 9 10 11 12 13 14 15
1425
FRONT BOARD LP-6404 +uP +C +5_ETF +5V6 +C +C
DISPLAY CONNECTION TABLE
Pin COM0 COM1 COM2 COM3 i a +RDS 3448
1 3452 3457
1e 1g 1f ROCK 10K 10K
A 1K5 A
2 1m 1i 1h POP f b
4.8V
2430 3447
3 1d 1l 1j 1a T452 T451 RDS_MPX
h j 4.7V T441 1n 10K
4 1c 1k 1b JAZZ TU_EN 3449
g k 9401 5.6V
5 2e 2g 2f I.S. foreseen TU_DATA 3451 22K
6 2m 2i 2h DBB m l 5400 3401 3400 6400 +RDS
7 2d 2l 2j 2a TU_CLK 470R 3454
e c 1u5 15R 10R 4.8V
8 2c 2k 2b NEWS 1N4148
1 2 3 4 5 6 7 8 2402 STEREO 3456 1K 6401
2401 2400
9 3e 3g 3f EON i d 100u 10n 10n 1N4148
37 36 35 34 33 32 31 30 29 28 27 26 25 24 23 22 21 20 19 18 17 16 15 14 13 12 11 10 9 8 7 6 5 4 3 2 1
1K 1416 FE-ST-VK-N
10 3m 3i 3h RDS 16
11 3d 3l 3j 3a 2431 2432 2433 2434 +RDS
To uP pin no.95 To uP pin no.55 4.6V T401 15
B 12 3c 3k 3b SIDE B +Keys 4n7 100p 470p 100p TU_EN / MPX B
LCD(1:50) T402
13 4e 4g 4f SIDE A 14
TU_DATA
14 4m 4i 4h Y3 T403
To / From COMBI BOARD

13
15 4d 4l 4j 4a 4.5V TU_CLK
2403 T442 T404
80 79 78 77 76 75 74 73 72 71 70 69 68 67 66 65 64 63 62 61 60 59 58 57 56 55 54 53 52 51 12
16 4c 4k 4b Y1 100n /STEREO
+uP
SEG11
SEG12|P93
SEG13|P92
SEG14|P91
SEG15|P90
SEG16|P67
SEG17|P66
SEG18|P65
SEG19|P64
SEG20|P63
SEG21|P62
SEG22|P61
SEG23|P60
SEG24|P77
SEG25|P76
SEG26|P75
SEG27|P74
SEG28|P73
SEG29|P72
SEG30|P71
SEG31|P70
SEG32|P87
SEG33|P86
SEG34|P85
SEG35|P84
SEG36|P83
SEG37|P82
SEG38|P81
SEG39|P80
VDD2
17 5e 5g 5f Y2 5401 3402 BKLT_ON 3459 T405 11
81 50
BKLT_ON
18 5m 5i 5h RECORD SEG10 VSS2 1u5 100R AUX_STR 220R 3461 T406 10
19 5d 5l 5j 5a PIN 55 to 63 2.8V 82
SEG9 VASS
49 2405 2404 AUX_DATA 3463 4K7 T407 9
AUX_STR
20 5c 5k 5b PROGRAM
21 6e 6g 6f CD
PIN 68 to 95 2.8V 83
SEG8 VAREF
48 4.5V
10n 100u
AUX_CLK 4K7 3465 T408 8
AUX_DATA
C AUX_CLK C
84 47
22 6m 6i 6h REPEAT SEG7 AIN7|P57 MUTE 3467 4K7 T409 7
23 6d 6l 6j 6a 85 46 4.5V KEYS_AD2 MUTE
SEG6 AIN6|P56 PWM 2K2 3469 T410 6
24 6c 6k 6b SHUFFLE 4.5V KEYS_AD1 PWM
86 45
25 7e 7g 7f TIMER SEG5 AIN5|P55 470R T411 5
87 44 0V 3490 TA_SH_CLK D_GND
26 7m 7i 7h ALL SEG4 AIN4|P54 +5V6 T412 4
27 7d 7l 7j 7a 88 43
0V 3492 1K TA_SH_DATA +5V6
SEG3 AIN3|P53 PWRDWN 3471 T413 3
28 7c 7k 7b DOT 0V 1K 3494 TA_SH_STR /PWRDWN
29 8e 8g 8f COLON
89
SEG2 7400 AIN2|P52
42
33K T414 2
2435 470p
2436 470p
2437 470p
2438 470p
2439 470p
To Backlight-Board
3472 470K
3486 1K /BKLT
2n2
10n
90 0V TA_ADC2
D
30
31
8m
8d
8i
8l
8h
8j
FM
8a 91
SEG1 TMP87CM23F AIN1|P51
41
40 0V 100R 3488 TA_ADC1

1
+A D
2440
2441
SEG0 AIN0|P50
32 8c 8k 8b MW 92 4.7V 3418 100R EEPROM_CLK 1417 EH-B
39
33 AM LW STEREO TUNER COM3 P36 12.5V 2
93 38 4.7V 1K5 3419 EEPROM_DATA +A
34 -- -- -- COM3 COM2 P35 4V 1
35 -- -- COM2 -- 94 37 0V 3475 1K5 CD_RESET +C /BKLT
COM1 P34
36 -- COM1 -- -- 95 0V 330R 3477 CD_DATA
36
37 COM0 -- -- -- COM0 P33
3403 0.96V 96 35 0V 3479 470R CD_SICL 3483
+uP VLC P32
6K8 97 0V 470R 3481 CD_SILD 15K 1418 FE-ST-VK-N
2406
E RDS DECODER 3404
1K8 10n NC1 P31
34
CD_RESET 3474 1 E
3453 470R
INTS_|STOP_|P20
98 33 0V TU_DATA /RESET
NC2 P30 1K T421 2
To CD99
INT2|TC1|P12
+RDS +C +uP 99 0/4.7V 1K 3484 DOORSW D_GND
INT3|TCIP40
32
NC3 P17 CD_DATA 3476 T422
XOUT|P22
SCK1|P42
SCK2|P45
PWM|P41
10K
INT0|P10
INT1|P11
CD_DATA
PPG|P14
SO1|P44
SO2|P47
DV0|P13
3442 33K
TC2|P15
RESET_
100
S11|P43
S12|P46
31
XIN|P21
+uP VDD1 P16 CD_SICL 3478 470R T423

foreseen
XOUT
4
VSS1
TEST
CD_SICL
9400
3443 33K
P00
P01
P02
P03
P04
P05
P06
P07
XIN
7406 3405 2407 T424

CD_SILD 470R 3480 5
SAA6579T 1K 100n CD_SILD
RESET 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30
1 2 16 15 DOORSW 3482 1K T425
1.7V
4.5V
2.4V
2.2V
6
4.7V
2.3V
0.8/4.6V
2V
0/4.7V
2V
4.7V
4.2V
DOORSW
4.5V
0V
0V
0V
0V
0V
0V
5V
0V
DIFFERENTIAL RDDA
RDCL
QUAL
T57
3407 1K T426
2408
3444 100n 1K +C
3440
3409
3450
3458
3462
3466
3473
3439
2442 2443 2444 2445 2446
10K
10K
4K7
4K7
4K7
F 100R 5402 F
1K
1K
1K
2410 8MHz T443 0001 DIPMATE
GENERATOR
0V 7402
To MTF
220p 220p 220p 220p 10n
* 3485
DECODER
BC847B 10n 5403 1

QUALITY
2424 4.5V T444 TAPE_REC

2412 15p
2413 68p
3406 32K768
VSSD 11 2409 3497 2K2
BIT
10K
2
12 VDDD 100K 2411 TAPE_PLAY
470R
100n
3413
3470
3441
3455
3460
3464
3468
3414
2416
10n
2K7
4K7
2K2
33K
27p
2415
1K
1K
1K
15p TA_ADC2
TEST LOGIC AND OUTPUT
27p
*
SELECTOR SWITCH
TA_ADC1 3487 1420 FE-ST-VK-N

3445
OSCILLATOR
1
TEST 10 2K2 TA_ADC2
3498
DIVIDER
DECODER
10K
14 OSCO
BIPHASE
2K2 RDS_DATA T431

*3495 *3496
SYMBOL
220K
3446
AND
FREQ_SHIFT
5404 3408 *2447 *2448 2
TA_ADC1
To TAPE
T445 OSC 56K T432
RDS_DATA
AUX_DATA
470K 2414 470p 470p 56K 3
ROTARY2
PWRDWN
ROTARY1
RDS_CLK
AUX_STR
BKLT_ON
AUX_CLK
RDS_CLK 7403 +5_ETF +5V
STEREO
G 10n G
TU_CLK
13 OSCI
TU_EN
AT-51 BC847B 4
MUTE
T446 D_GND
PWM
RECONSTRUCTION
RC5
4M332 MODE 9 3489 T433
RDS_MPX TA_SH_CLK
2425
2426
33p
22p
5
TA_SH_CLK
3499
22K
T447 TA_SH_DATA 3491 1K T434

FILTER
6
+5V6 +C TA_SH_DATA
TA_SH_STR 1K 3493 T435 7
TA_SH_STR
3410 IR RECEIVER 1K T436
RC5
KEYS_AD2
EEPROM_CLK
EEPROM_DATA
KEYS_AD1
ROTARY1
ROTARY2
T449
100R 7404 7405
REGENERATION
3416 2449 2450 2451

FIXED DIVIDER
TSOP2836
VARIABLE AND
ST24C01B6 8
COSTAS LOOP
4.3V Communication 220R 470p 470p 470p

AND SYNC
T448
(8th ORDER)
BANDPASS
2 3415 4.7V 1 3417

CLOCK
5.3V E0 VCC
H 4V 15K 15K H
57 Khz
T453 V SUP
foreseen
2
3412 E1 EEPROM
4400
OUT 1 2419 ROTARY ENCODER

2417 100n 3 5
10K 2418 E2 SDA +C
47u 3411 +Keys +Keys
GND
1n 0V 6
100K SCL
COMPARATOR
3 4
VREF REFERENCE
VP1
4401 7
CLOCKED
VOLTAGE
MODE|WC_ VSS
ALIASING
FILTER
ANTI-
3429 4 3420 3437 3438 1415

VSSA 6
10K 10K 22K 22K EC16
KEY GROUP1 KEY GROUP2 2
SCOUT
3
VDDA
MUX
3436 3435 3434 3433 3432 3431 3430 3428 3427 3426 3425 3424 3423 3422 3421 1
CIN
I 5 I
5K6 3K3 2K2 1K5 1K 470R 5K6 10K 5K6 3K3 2K2 1K5 1K 470R 5K6
4 8 7 5 3
2428
* 2421 1400 2420 2422 2423 4
1414 1413 1412 1411 1410 1409 1408 1407 1406 1405 1404 1403 1402 1401
10n 10n 100p 100p DC VOLTAGES MEASURED IN TUNER MODE
2427 2u2
UNLESS OTHERWISE STATED
560p 2429 330p
(230V MAINS SUPPLY)
1 2 3 4 5 6 7 8 9 10 11 12 13 14 15
* ITEM
1412 2447 2448 3485 3487 3495 3496
MODEL
MC10 2K2 2K2 56K 56K
MC20 470p 470p 3K9 3K9 150K
PCS 104 565

6-2 6-2
FRONT BOARD - LAYOUT DIAGRAM
1 2 3 4 5 6 7 8 9 10 11 12 13 1 2 3 4 5 6 7 8 9 10 11 12 13
A A A A
B B B B
C C C C
D D D D
E E E E
F F F F
G G G G
H H H H
I I I I
J J J J
1 2 3 4 5 6 7 8 9 10 11 12 13 1 2 3 4 5 6 7 8 9 10 11 12 13
PCS 99 472
7-1 7-1
COMBI BOARD (Part 1) - CIRCUIT DIAGARM
1550 A1 2501 B10 2510 E9 2518 E11 2526 F13 2534 G14 2557 G6 2566 D6 3501 B9 3510 E9 3518 E12 3526 H12 3534 G13 3542 I14 3552 A3 3560 E4 3573 H8 3581 B7 3589 G7 7500-C F13 7505 D12 7513 B13 9551 C2 T504 E9 T557 C2 T566 F2 T574 G2 T582 I2 T590 H8
1551 B1 2502 B10 2511 D10 2519 E12 2527 B13 2535 B8 2558 I6 2567 B7 3502 B10 3511 C10 3519 E12 3527 B12 3535 C13 3543 B14 3553 B3 3561 E2 3574 F6 3582 D6 5550 E3 7500-D D13 7506 F12 7514 H13 9552 C2 T550 D5 T558 C2 T567 E3 T575 H2 T583 I2 T591 H8
1552 B2 2503 F14 2512 F10 2520 E12 2528 H13 2550 A2 2559 I6 2568 D7 3503 B10 3512 G10 3520 E12 3528 H12 3536 G13 3544 H14 3554 B3 3562 F2 3575 C5 3583 B7 5551 F3 7500-E D11 7507 B12 7550 H4 9553 D2 T551 A2 T559 D2 T568 F3 T576 H2 T584 I4 T592 I8
1553 C2 2505 B8 2513 C10 2521 C12 2529 C14 2551 A2 2560 I7 2569 B7 3505 C8 3513 D11 3521 E13 3529 C12 3537 A14 3545 C14 3555 C2 3563 G4 3576 C5 3584 D7 5552 C2 7500-F D10 7508 H12 7551 B4 9554 E3 T552 A2 T561 D2 T569 F2 T577 H2 T585 G4 T593 I8
1554 D2 2506 D8 2514 G10 2522 G12 2530 G14 2552 B2 2561 F6 2570 D7 3506 E8 3514 F11 3522 E12 3530 G12 3538 I14 3546 G14 3556 B2 3565 I4 3577 B6 3585 C7 6500 B10 7501 C8 7509 C12 7552 G7 9555 F3 T553 B2 T562 D2 T570 F2 T578 H2 T586 G7 T594 I8
1555 E2 2507 B9 2515 D11 2523 C12 2531 C13 2553 B1 2563 B5 2571 G7 3507 C9 3515 D11 3523 D12 3531 C12 3539 B14 3547 B15 3557 D3 3566 I4 3578 D6 3586 E7 6550 I5 7502 E8 7510 G12 7553 F5 T500 A8 T554 C2 T563 E2 T571 F2 T579 H2 T587 H8 T595 B7
1556 G2 2508 D9 2516 F11 2524 G12 2532 G13 2554 G4 2564 C6 2573 A4 3508 E9 3516 E11 3524 F12 3532 G12 3540 H14 3548 H15 3558 D3 3568 H5 3579 B6 3587 B7 7500-A F10 7503 C9 7511 B13 7555 B6 T501 B9 T555 C2 T564 E2 T572 F2 T580 H2 T588 H8 T596 D7
2500 A8 2509 C9 2517 D11 2525 C13 2533 C14 2555 H3 2565 B6 3500 A7 3509 C9 3517 D12 3525 B12 3533 C13 3541 A14 3551 A3 3559 E3 3572 G7 3580 D6 3588 D7 7500-B F11 7504 E9 7512 H13 7556 D6 T503 C9 T556 B2 T565 E2 T573 G2 T581 I2 T589 H8
1 2 3 4 5 6 7 8 9 10 11 12 13 14 15
COMBI BOARD
Source Selection / Sound Control part
SOURCE SELECTOR ELECTRONIC VOLUME CONTROL DIGITAL SOUND CONTROL (DSC)
+VS from 7552
2550 A1 A0 +VS
A 22n
2573
3500 T500
4.2V
0.57V 4.1V
BASS DBB A
2551
1550 4 100n 16 9 10 Vc to 7500 pin 14
2n2
2 T551 * 3551
VDD MSB LSB
+VS
820R
2500
3537
39K 220K
1 T552 * 3552
LOGIC 100u
BC847B 0/2.9V
*
3541
AUX
39K 7551 7511 220K
3 2552 *3554 *3553 3579
150K 4.2V 3501 2501
POP JAZZ
2527
2/2.36V
3539
2n2 6K8 6K8 HEF4052BP 3577 7555 470R 220u
0.54V
2553 BC847B 10n 22K
TAPE_L 1 LL 470R 4.35V
2569
B 22n
TUNER_L 5
2565 2567 3587 4.05V
4.1V 3502 3503 6500 PWM 7513 -0.3/0.56V 3547 BASS_ALC B
1551
LH H 2563
(MC148) 100p 2u2 1u T595 3K9 T501 3525 3527 BC847B
T553 470n 0.57V 2K2 470R 1N4148 from 1556 150K from
-CMOS 1552 -8V2 HL L
0V 3.6V 3583 220K 220K
AUX_L 2 3 2502 3543 Amplifier Part
7 3.75V 4K7 7507
T556
* 3556 22K
2535
100n
TAPE_R 2505 2507 10u 0/2.65V BC847B 82K
Recorder Board
6 6 CD_L 4 HH 3581
+12A +5V6 *555295512u2 +5V6_S 2K7 100p
3.55V
0V 100p
2529
to/from
3575
TAPE_L
5 5
T554 * +12V_AF
15K 3585 3.6V 0V 2521 3529 100n
4 4 T555 2K2 3545
GND * 3555 22K
TAPE_R 12 LL
7501
ON4986
3507 7503
ON4986
0/2.1V 1n5 27K
8K2
3 3
T558 REC_R 15R 2531 2533
C REC_R
2 2
T557
from
TUNER_R 14 LH H
3576 0V 3.55V 3.55V
3.6V 0.2V 2513
0/2.65V
100n 47n
C
REC_L 3585, 3586 3.6V 2509 0V T503 0/2.1V
15K
1 1 2523
REC_L AUX_R 15 13 +VS 47p 3531 3533 3535
FE-BT-VK-N
FE-BT-VK-N HL L 0.2V
22p
7509
Recorder Board
3511 680p 27K 33K 100K

*9552 +CD_MTF_MOTOR 3505 3509 BC847B
MTF / ETF
1553 CD_R 11 HH 2525

T559 2564 33K 33K 100K
+Motor
2 *9553 470n 3580 Vc 2.05V 47p Vc
to
+12V VSS VEE

GND 150K 4.2V 1V 2.13V
1 7556 14 12 14
8 7 6 3578 0.54V 2511 2.05V 3523 9 8 2.1V 1.1V L
EH-B BC847B
T550 470R 4.35V 220n 13 7500-E Vc 2.05V33K to
2570
D 1554 2566 2568 3588
7500-F
7
HEF4069UBP 0V BC847B 7500-D
HEF4069UBP
7
Amplifier Part D
CD_L
1 T561
* 3557 100p 2u2 1u T596 3K9 HEF4069UBP 2515 3513 2.05V 11
14 2.05V 7505
10 2.08/2.1V
2 33K 0V
GND Source Selection 0V 3.6V 3584 15K
10n
CD Board
2.05V 7
* 3558 Logic Table 3.75V 4K7
to/from
3 T562
CD_R 2506 2508 2517 3515 3517
Source A1 A0 3582
4 33K 3.55V 0/2.64V
+5V
T563
CD_+5 *3559 *3560 TAPE 0 0
2K7 100p 0V 100p 1n5 33K 100K
5 3K3 3K3 3586 3.6V 0V 3519 3521
GND 2519
AUX 1 0 2K2 3508 220K 33K
6 7502 7504
+SERVO +CD_MTF_MOTOR 220p
TUNER 0 1 ON4986 ON4986
T564 15R
E FE-BT-VK-N
CD 1 1 0V 3.55V 3.55V
0.2V
INCR E
3.6V
1555 9554 (forseen only) 3.6V 2510 0V T504 2520
LEFT
1 T565 * 3561 REC_R 22p 0.2V 220p
3520
220K
3522
5550 33K
2 15K T567 to 1551 or 1552 3506
GND REC_L 3510 2518 3516 3518
470n 33K 33K 0/2.64V
3 T566 * 3562 Vc
Tuner Board
RIGHT 1n5 33K Vc 100K

15K T568 5551 Vc 2.05V
to/from
4 7553 14
VCC +12V_AF 5.27V 2516 3514 0V 3 4 2503
5 470n 0V 0V BC327-40 2.05V
T569
TU_EN / MPX CD_+5 +5V6 7500-A 10n 15K 7500-B 2.05V7506 2.08/2.1V 7500-C 22n
7 0V BC847B
6 T570 HEF4069UBP HEF4069UBP HEF4069UBP
F TU_DATA 9555 (forseen only)
3574
2512
14
2 2.05V
2.05V
3524
14
6 2.1V R
F
7 T571 47K 1 5
TU_CLK 4.65V
8 5.5V 220n 1V 33K 1.1V to
T572 CD on = Low 7 7 Amplifier Part
/STEREO 4.9V 2.05V 2.13V
5.7V
5V 5.35V
FE-BT-VK-N 2526
2561 5.5V
3563 0.55V T585
1556 +5V6_S +VS 22u 3589 5.7V 2571 3512 47p
T573 +5V6_S 100R +5V6 0/2.1V 2524 3532 3534 3536
+RDS 220R 470n 100K
16 2554
5.5V 680p 27K 33K 100K
TU_EN / MPX 220u T586 2514
15 5.35V 5.7V 3572 2532 2534
BC847B 0/2.65V
G TU_DATA
14
10K 16
7552 47p
7510 100n 47n
G
TU_CLK 2557 HEF4094BP
13 470n SRG8 2522 3546
15 0/2.1V 3530
/STEREO EN1 8K2
uP Port Extension
to/from Front Board
12 2530
T574 0V 4.2V 4V 1 1n5 27K
BKLT_ON STANDBY STB
11 0V 0V
T575 0V 3 100n
AU_STR 0/2.65V BC847B 3544
10
T576 0V 0V 0V 7508
AU_DATA LOGIC TABLE 82K
9 3526 3528 BASS_ALC
T577 0V 0V 0V 2 4 0/5.5V T587 7514 3548
AU_CLK D 1 JAZZ Sound features Control lines 220K 220K
8 MUTE 150K
T578 3.3V 0V 0V 5 0/5.5V T588 -0.3/0.56V
H MUTE
7
T579 3.14V 3.84V 3.73V
0V 3.9V 3.9V
6 0/5.5V T589
POP DSC DBB DBB POP BASS JAZZ
BC847B
from
Amplifier Part
H
PWM PWM 3.5V INCR off off 0 0 1 0
6 2555 0V 3.5V 3568
to 6500 7550 7 0/5.5V T590
D_GND 2u2 +12V BASS (flat) on 1 0 1 0 BC847B
5
T580 BC817-25 1K 3573 2528 7512 3540
+5V6 14 5.7V 0.67V 5.5V T591 CD 1 0 1 0
POP JAZZ
+5V6 off
4 2.85V Rock
T581 T584 13 0/5.5V T592 1K 10n 22K
/PWRDWN 0V DBB on 1 0 0 0
3
T582 2.85V 3565
BACKLIGHT 12 0V T593 5.5V 5.35V
2/2.36V *3542
/BKLT A0 to Source Sel. off 0 0 1 1 0/2.9V
2 22R Jazz 220K
6550 11 0V T594 0V 5.35V 7554
+A +12V A1 on 1 0 1 1
1 BZX79-C3V3 3538
T583 2558 2559 2560 9
I FE-BT-VK-N 3566 220p 220p 220p Pop
off 1 1 1 1 220K
I
10 on 1 1 0 1
22R
BASS DBB
PWRDWN
8
from
Supply Part
1 2 3 4 5 6 7 8 9 10 11 12 13 14 15
* (230V MAINS SUPPLY ) DC VOLTAGES MEASURED IN :

Item 3541 3551 3553 3555 3557 3559 3561 5552 9551 9552 9553 V CD Mode 1KHz , 0dB track, DSC "OPTIMAL", DBB "OFF", INCR "OFF", VOLUME "20"
Model 3542 3552 3554 3556 3558 3560 3562
V Tuner Mode 1KHz , df "22.5kHz", DSC "OPTIMAL", DBB "OFF", INCR "OFF", VOLUME "20"
MC10 220K 39K 6K8 22K 33K 3K3 15K 2.2uH V Standby Mode
MC20 150K 33K 8K2 6K8 18K 2K7 10K V DSC OFF/ON at CD Mode 1KHz , 0dB track, VOLUME"20"
PCS 104 566
7-2 7-2
COMBI BOARD (Part 2) - CIRCUIT DIAGRAM
1330 A13 2331 E4 2334 D5 2337 E9 2340 D9 2343 B11 2346 E12 2349 H10 2353 H7 3331 E5 3334 D5 3337 F9 3340 B10 3343 E9 3346 D9 3349 G7 3352 G11 3356 B5 3360 I5 3363 C7 4333 E5 5331 E9 5334 C9 6333 H5 7331 G8 7334 B4 T330 B6 T333 C7 T336 H6 T339 D13 T342 E13
1331 D13 2332 D4 2335 E5 2338 D9 2341 A11 2344 B11 2347 F11 2351 B6 2354 H8 3332 D5 3335 E9 3338 D9 3341 B11 3344 D9 3347 G8 3350 I7 3353 G10 3358 B5 3361 H6 3364 B8 4334 D5 5332 D9 6331 G11 6334 C8 7332 G7 7335 B8 T331 H6 T334 G10 T337 B12 T340 E13 T343 E4
2330 C7 2333 E5 2336 D5 2339 F9 2342 B11 2345 D12 2348 F10 2352 I5 2355 C8 3333 E5 3336 D9 3339 A10 3342 B11 3345 F9 3348 G7 3351 G11 3354 B4 3359 H5 3362 B8 3365 B9 4335 A5 5333 E9 6332 G10 7330 D6 7333 H7 9330 B8 T332 C7 T335 H8 T338 B12 T341 E13 T344 D4
1 2 3 4 5 6 7 8 9 10 11 12 13 14 15
COMBI BOARD
Power amplifier part
A A
HEADPHONE SOCKET
4335
MUTE * 3339 2341
7
68R 1330
47u
+5V6 (MC148) *3341 2343
L 4
9330 4K7 1n
+AMP T337 L 3
(forseen only) 3356 9.8V

2 16 - 150 ohm
22K 9.9V *BDW93CFP *3342 T338 R
B 3358 T330 10.4V 7335 4K7
2344
1n
5
B
R 6
3354 4K7
11V
11.1V
11.1V
* 3340 2342
1
10K 2351 11V 68R 47u
7334 4u7 *
3362 11.1V 3364 * *3365
BC847B 2330
* 11V
3363 1K8 390R 270R
4u7 10K
* 2355 *6334
100u BZX55-B11
C (MC118)
C
T333
T332
5334
360n
(forseen only) 7330 3346 2340
3338
2334 AN7125 10K 220n
1
MC148 2R2
150n VCC 5.8V
D T344 2332 3332 OUT1+ 2 4.7V 5332 D
R 3344
150n 10K 4334 360n
0V 6 IN1 GND1 3
10K
3334 2336 MC148
3.1V OUT1- 4 4.7V 5.8V 3336 1331
6K8 220p T339
(forseen only) 3.25V 2338 2345 L 1
2R2
0V 220n 22n T341 LS BOX
5 STB L 2 8R
STB left
from 0/2.2V 9 MUTE VREF
T342 R 3
MUTE LS BOX
Source Selection and Sound Control Part MC148
(forseen only) 2346 T340 R 4 8R right
OUT2- 10 4.7V 5.8V 5331
2333 22n
E 0V 8 IN2 GND2 11
360n Clickfit
socket
E
150n MC148 3343
T343 2331 3331 OUT2+ 12 4.7V 5.8V 3335
L 10K
150n 10K 4333 2R2 2337
GND 220n
3333 2335
5333
6K8 220p 7
(forseen 3345
only) 360n
10K
3337
2R2
F 2339 F
220n
+12V +12V
2348 2347
* Item 2355 3339 3341 3348

POWERSTAGE
PROTECTION
47u 47u
3364 3365 6334 7335 3347
Model 3340 3342 3362 3363 22K

3349
22K
6332 6331
47K
G MC10 100u 68 4K7 1K8 10K 390 270 BZX55-B11 BDW93CFP 1N4148 1N4148 G
T334 3353 3352 3351
MC20 120 560 BC857B
7332
BC857B
7331
MC148 BASS_ALC 1K 1K
MC148 7.2V 47R
7.2V 6.2V 6.2V to 3547/3548
T336 T335 DIGITAL SOUND
CONTROL (DSC) 2349
100u
2353 2354
0V
T331 680p 680p
H H
6333 3359 3361
STANDBY
1N4148 6K8 100R 7333
BC847B
2352 3360
47u 100K 3350 (230V MAINS SUPPLY ) DC VOLTAGES MEASURED IN :
47K
V CD Mode 1KHz , 0dB track, DSC "OPTIMAL", DBB "OFF", INCR "OFF", VOLUME "20"
I I
V Standby Mode
V MUTE OFF/ON
1 2 3 4 5 6 7 8 9 10 11 12 13 14 15
PCS 104 567

7-3 7-3
COMBI BOARD (Part 3) - CIRCUIT DIAGRAM
0250 G11 2250 E6 2254 E11 2258 G5 2262 D15 2266 B15 3251 A8 3255 B14 3259 C15 3263 D14 3267 F17 3271 H14 3275 H15 3279 J19 3283 C17 6251 D4 6255 D8 6259 D10 6263 E10 6267 B7 6271 H8 6275 J17 7253 C19 7257 I15 7261 K19 9254 E18 T251 E2 T255 E12 T259 I4 T263 I19
1250 D2 2251 D8 2255 F11 2259 G5 2263 C18 2267 E6 3252 H5 3256 B14 3260 C16 3264 C19 3268 F17 3272 I14 3276 J17 3280 K19 3284 C17 6252 E4 6256 D9 6260 E8 6264 E10 6268 B8 6272 B16 7250 A14 7254 E17 7258 I14 9251 D6 9255 I12 T252 F2 T256 F6 T260 J4 T264 J19
1251 E3 2252 D11 2256 A6 2260 H7 2264 C15 2268 F12 3253 H5 3257 B15 3261 D16 3265 E16 3269 G16 3273 I14 3277 K17 3281 C17 4250 B19 6253 E4 6257 D10 6261 E8 6265 E10 6269 G6 6273 E18 7251 C14 7255 G17 7259 J15 9252 B19 9256 E16 T253 F3 T257 I4 T261 A19
1252 I3 2253 E8 2257 B7 2261 B14 2265 D19 3250 A6 3254 H7 3258 B15 3262 C17 3266 F17 3270 I12 3274 K15 3278 J18 3282 C17 6250 D4 6254 D8 6258 D10 6262 E9 6266 A7 6270 H6 6274 I12 7252 C16 7256 H16 7260 J18 9253 E4 T250 D3 T254 E6 T258 I4 T262 E18
1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21
COMBI BOARD
Supply part
A BDW94CFP
12.2V A
17.7V
*3250 *2256 *6266 *3251 -8V2 +A
18.4V 7250 12.2V 0V T261
+12V BACKLIGHT
470R 2K2 21V
22u 1N4148
2257 * *6268 MC20
-8.2V
* 2261 * 2266
ETF_MOTOR (MC20)
BZX79-F8V2 -8.2V -8.2V
*6267
10u 2u2 100n * 9252 +AMP
6272
B 1N4148
3258
BZX79-F10 B
(MC20)
3255 3256 3257
47K * 4250 +12V_AF TUNER
1K 1K 1K 2.3V
2.3V
21V
3281 2K2
0V *3284 *2263
3282 2K2
3283 2K2
17.8V 18.4V
7251
0V 2K2 47u *7253
C 7.9V ac
8.3V ac
BC847B 0.57V
BC847B 3260
BC368
+12V_AF TUNER C
0.57V
8V ac 2264 *
3259 7252
330R
220K * * ETF_AF
MC20 0.58V
47u
3262 *3264 (MC20)
0V 1K
T250 * 3263 3261
1K
13V
STANDBY
1K
2262
1n
0.58V
82K *2265
MC20 100u
D * 6250 13.7V 9.2V
10.6V 9.8V
D
from Mains Transformer
*1250
1N4003
* 9251 +AMP 2251 6254 6255 6256* *6257 *6258 6259 2252
1 *1251 *6251
15V 100n 1N4003 1N4003 1N4003 1N4003 1N4003 1N4003
100n 19V
19.4V
MC20
18.8V 9.2V
15.7V ac 1 21.7V 19.8V (forseen only) 0.4V
11.6V ac 2 T251 1N4003 21V
11.8V ac
16V ac
2 * 9253 T254
+B
T255
+A
3265
9.8V
16.5V ac 3
MC20
E 12.2V ac
4
3
*6252 1R BC369 13V E
7254 13.8V T262
EH-B 1N4003 * 2250
* 2267 2253 6260 6261 *6262 *6263 *6264 6265 2254
+B
9256 9254
+CD_MTF_MOTOR CD SERVO
EH-B
T252 *6253 4m7 3m3 100n 1N4003 1N4003 1N4003 1N4003 1N4003 1N4003 100n
* * 3266
0.4V
6273
MTF_MOTOR (MC10)
2255 2268
1N4003 47K 15V 12.3V
3m3 4m7 13V 1N4003
15.8V ac (forseen only)
F 16.6V ac T253
8.5V
10.6V
F
16.1V ac 3267 3268
9.1V 2K2 2K2
MC10 T256
MC20 0.14V 0.14V
10.6V
0.7V 0.14V 15V
3269 0.7V 0.14V
STANDBY 7255 MC20
2258 2259 PAD 22K 0V
G 4u7 4u7 0250 P_GND D_GND A_GND BC847B G
to
6269 Recognition BOTTOM
Mains Breakdown 6.2V PLATE
1N4148 6.2V
6270 3254 6.2V
PWRDWN MC20
1N4148 9.1V
H 3252 3253
2K2
2260 6271 +C 10.6V 9.8V 3275 H
4K7 4K7 47n BZX79-F6V8 470R
BC327-25
3271 12.9V 13.8V 15V 7256
4R7
MC20
(no L.P.S.) 9.1V 12.9V 5.35V
BC327-25
3272 10.6V 9.8V 13.8V 15V 7257 5.5V T263
I 1252
1
T257 +B
9255
+5V6 uP I
4R7 5.7V
T258 12.9V MC20 CD
to 2
+C 3270 6274 BC327-25 8.4V
Low Power Standby (L.P.S.) 3
T259 3273 13.8V 15V 7258 10V 9.3V BC807-255.35V
Transformer 1N4003 7260 5.5V T264
T260 3R3
4 4R7 9.1V 13.3V 3276 6275 +5V6_S AF
STANDBY (L.P.S.) (L.P.S.) 0.5V
10.6V 14.5V 2K2 RDS
BZX79-F3V3
EH-B MTF_AF (MC10)
J J
* Item
9.8V
MC10
7259
12.3V
2.85V 2.8V 2.7V

3278 4.8V 5.67V
47K 4.6V
ETF_LOGIC (MC20)
1250 1251 2250 2255 2256 2257 2261 2263 2264 2265 2266 2267 2268 3250 3251 3263 BC847B 3279
Model 2.35V 2.2V 2.1V 0V 1K
3M3 0V 5.67V
4M7
MC10 16V 25V
2u2 47u 47u 1K
3277 7261 3280
3274 STANDBY
K 3M3 4M7
390R 2K2 BC847B
0.65V 22K
K
MC20 22u 10u 4u7 100u 100n 16V 25V 470 2K2 4K7 0.65V
0V
Item 6250 6252 6256 6258 6263 6266

3264 3282 3283 3284 4250 6251 6253 6257 6262 6264 6267 6268 7253 9251 9252 9253 (230V MAINS SUPPLY ) DC VOLTAGES MEASURED IN :
Model
L V CD Mode 1KHz , 0dB track, DSC "OPTIMAL", DBB "OFF", INCR "OFF", VOLUME "20" L
MC10 1N4003 1N4003
MC20 1K 2K2 2K2 2K2 1N4003 1N4003 1N4003 1N4148 BZX79-F8V2 BC368 V Standby Mode
1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21
PCS 104 568

7-4 7-4
COMBI BOARD - LAYOUT DIAGRAM
1 2 3 4 5 6 7 8 1 2 3 4 5 6 7 8
A AA A
B BB B
C CC C
D DD D
E EE E
F FF F
G GG G
1 2 3 4 5 6 7 8
H H
1 2 3 4 5 6 7 8
PCS 99 476
8-1 8-1
TUNER BOARD ECO6 - CIRCUIT DIAGRAM
1 2 3 4 5 6 7 8 9 10 11 12 13 14 1101 A2
1102 B1
6120
7101
C13
C8
1103 E2 7103 H8
1110 B2 7104 D2
VERSION PROGRAMMING COMPONENTS 1120 E14 7105 F4
TUNER BOARD ECO6 / SYSTEMS-CENELEC

AM-IF1 VERSION
1130 A2
1131 B2
7109
7110
H3
H12
6120 3156 3157 3170 7111 1132 F13 7111 C13
5111 450kHz 2106 E3 7112 G12
A 4 3
T113
/00 /02 FM/MW/LW A 2107 E4 7122 H4
1101USA 2 2108 G3 7124 H7
2109 G3 T102 B2
6 1 2150 /00 /02 FM/MW
3 1130 AM-IF2 2118 H6 T103 B2
2119 H6 T104 B6
100n 5112 450kHz
2 8 7 2120 H6 T105 E2
C-PAD 3 4 /01 FM/MW
1
2122 I6 T106 E2
T115 T114 2 2123 H6 T107 C3
YKD21
/14 FM-OIRT/MW
A FM 75 OHM 1110 FM FRONTEND FE450 1 6
2124 H6
2125 H6
T109
T110
D5
D5
1102 FM-IF1 FM-IF2 2127 E7 T111 E5
7 8 /17 FM/AM
T102 0V 1 3190 T104 3191 5109 7P 2128 B8 T112 F7
B 1
MIXER
7
IF-OUT
0V 5110
B 2129 C7 T113 A9
120R 120R I 1 O 3 I 1 O 3 component mounted
1131 T103 ANT AM-AFC 2130 F11 T114 B11
YKD31- 2 2128
0432 2131 F8 T116 F10
330R
5114 450kHz
3192
8 0.1V G G
2 2 2132 F8 T117 F13
0.7V 1.1V
C-PAD OSC. AM/FM 3 4
Vvaricap
10u 2133 F8 T118 G11

OUT D
330R
3193
GND VCC 2 2134 I8 T120 F13
1.4V
0.2V
1.4V
1.4V
0.4V
1.4V
9V
0.7V
1.4V
7101 2135 I9 T121 F13
1 6 VERSION DETECTION 2136 H14 T122 E13
2 3 4 6 5 9 10 TEA5762 44 43 42 41 40 39 38 37 36 35 34
2137 H13 T123 E13
AM-MIXOUT
AM|FM
1.6-8V
7 8
AGC
NC
RF-GND2
AM-IF1-IN
VSTABA
FM-IF1-IN
AM-IF2
FM-IF2
VSTABB
7.2V
2165 7P P1 6120 2138 F9 T124 G14

AM DET 2139 G9 T125 F14
100n 1.2V
C 2129 2V 0.7V
BAS216
C 2140 G9 T126 F13
PROGRAMMABLE
T107 AM-IF 2141 F10 T127 F13
100K
OUTPUT PORTS
3156
1 RIPPLE FM-IF2-IN 33
3195 AGC P1 0.2V 2143 G12 T140 F11
3194
2K2
+FM 100u FM
AM AM 2144 G11 T141 F10
100R 0V 2 IF1 0V
2161 p
32
p
AM-RF FRONTEND MIXER AM-AFC 7111 2145 E11 T142 F10

100n
100n
2190
C CTRL
1.4V
P0
BC847C 2146 E12
2147 E12
100K
100K
3170
3157
3 FM-GND
AGC AM FM P1 31 7.5V
AM 2148 E12
2163 LW
IF IF2
OSC 2149 H7
100n
3105 T109
4 RF-GND1 P0 30 7.5V 2150 A10
CONTROL
AGC
220R CONTROL 0.1V 2159 D5
BAS216
3161 2161 C11

D 0.1V 5 29 0V
D
6106
FM-OSC PRE- MULTI- WRITE-EN

LW only SCALER PLEXER
2162 H12
22K 2163 D11
0V T110 3160
0V 6 AM-OSC DATA 28 0V 2164 G10
3108 0V 7104
AGC
RIPPLE VSTABA VSTABB 470R 2165 C7
2K2 0.7V BC337-40 VDD 3159 2166 E11
27 0V
2159
7.8V 7 VCC1 CLOCK

33p
5V 152kHz, 50mVpp
VCC1 STABILIZER 2167 E11
P01 LW =HIGH 8.2V AGC AM 3169 2166 470R 2169 G8
2148
2147
220p
2146
220p
1.6-8V 8 I-TUNE DET DIG-GND 26 2190 C3
2n2
CHARGE
MW/LW-RF PUMP
150K 1n
1-8V 0V 3105 D5
1 6105-1 2
VCO 3142 FM 5121 2167 stereo mono stereo 3108 D2
T111 1V 9 VCO XTAL 25 1.4V
7 DET 3109 G4
3141 1.3V VCC2 OSC 12p
E HN1V02H 0.7V 10 AF-OUT MONO/
DT-381 75 kHz
24 stereo 0.2V 3 stereo 0.4V
E 3123 H3
3125 H2
56K
2107
AM FRAME AERIAL 100K mono 4.8V 3128 H3

1u
STEREO mono 4.8V

1103 5102 8 MW 2127 3132 G4
1120
2145
220p
7 11 MPX-IN STEREO 23
T105 VDD
8.2V 3158 T123 3134 H6
FIELDSTR-IND
STEREO
1 220n 1.2V DECODER AFC
VCC2 8.3V 3137 H7
FM-DEMOD
2
4101 * 6 1 5115 8
20p_LW
T106 470R 0V T122

2106
4 6 CLOCK 3141 E7
11p
7.5V
IF-GND
FILTER
RIGHT
PILOT
MUTE
1 5 2 7 3142 E6
0V T121
AFC+
0R
LEFT
AFC-
8 DATA
LPF
XH-S VDD 3143 G7
4 3 T112 6
0V T120 ENABLE/MPX
to/from
7 from 3144 G8
7KL
5 12 13 14 15 16 17 18 19 20 21 22
2169 MPX
0.15V
1.1V
0.8V
0.6V
0.6V
1.1V
3145 F8
0.8V
1V
11V
2V
* T127 5
1V
0V
T140 3168 3167
1.2V
4102
7.8V 12Vtyp VCC 3146 G13

0R
6105 VCC1
F 3 2 1 8.2V 120R 120R (10-14V) T126 4 F 3150 H12
2141 T116
1 8 RIGHT
3151 H12
T141
T142
2130
8.2V
22n
3
470n 2133 2K2

VCC2 T125 GND
3145
3152 G14
B LW only
2 7
2138
100n
3153 G13
2u2
BIRDY FILTER 2
1132
C-PAD
2131
470n
3 6 LEFT 3154 F13
1u
5103 LW 7105
1 3155 G12
470n 11V T117 3154
2132
3 BC337-40 4 5
4 VCC2 FE-BT-VK-N 3156 C12
HN1V02H 2164 330R 3157 D12
2109
2108
100p
2 0.7V
10p
BZX284-C11
3172
5K6
0.1V 3158 E13
RDS only T124
2139
6107
1 12V
4
15p
6 3159 D13
AM-OSCILLATOR
3109
2
4K7
9.6V 3160 D13

8 7 VCC1 7112
3161 D13
G G
6105-2 3
HN1V02H 6
BC547C
3167 F12
MW=HIGH
3143
22K
T118 3168 F11

5119 8.2V 3155
470R
470R
3171
3146
3153
3152
2143
220n
22R
47K
VDD 3169 E11
4 3
5
P0 5123 MW 3144 2169 MPX 8.3V 150R 3170 D12

1.3V 3171 G12
3132
2140
2144
4 3 2 7.5V
47R
82p
1u
1K 2n2 to 1120 3172 G12
22p LW
2118 p
3176 pin 5
2120
2 0.7V BC857C 1 3176 H7

2p2
18p
8.9V
2137
220n
2136
220n
33K 7103 6 3180 I3
VDD VDD 6 1
BC857B
8 7 3190 B6
2149
33p
MPX
7110
3191 B7
8 7 DISCRIMINATOR 8.9V
BUFFER AMPLIFIER
3151
2162
3192 B6
68K
22u
p
+FM
3123
3134
2119
2125
560p
H H
4K7
22K
10p
8.3V 3193 B4
7.5V 3194 C4
P0 3125 8V BC857B 5122 LW 8.2V 3195 C3
7122
4101 E2
P01
10K 6.7V 7109 BC847C 0V 4 3 0V
4102 F3
4104 *
0V
2124 *
3128 0V 0.7V 3137 P0
3150
2123
390p
LW=HIGH 0V 2
10K
7124 4104 H5
10n
0R
7.4V 2K2 0.7V BC847C 0.1V 22K MW=HIGH 5102 E3

6 1
5103 F2
3180
10K
5109 B9
8 7
2122
5110 B10
3n3
AM/FM
from 7101/39 5111 A9
5112 A11
I I 5114 B11
5115 E7
marked components not for LW version 5119 G9
22nUSA
22nUSA
5121 E11
2135
2134
15n
15n
5122 H5
5123 G5
6105-1 E4
6105-2 G6
ECO6 Sys-Cenelec, 990913
6106 D4
6107 G13
1 2 3 4 5 6 7 8 9 10 11 12 13 14
LEGEND ...V FM mode stereo Signal path
* ... only assembled in FM/AM-version SMD jumper
p ...for provision only 41xx
...V MW mode FM
USA ... for USA version only AM
0R V EVM ...V LW mode
LW ... for LW version only MPX (Audio Frequency)
voltages measured while AF - left/right
set is tuned to a strong transmitter
PCS 99 477
8-2 8-2 8-2
TUNER BOARD ECO6 - LAYOUT DIAGRAM TUNER ADJUSTMENT TABLE ( ECO6 Cenelec FM/MW - and FM/MW/LW - versions with AM-frame aerial )
Waverange Input frequency Input Tuned to Adjust Output Scope/Voltmeter
VARICAP ALIGNMENT
FM 108MHz check 8V ±1.2V
87.5 - 108MHz
(50kHz grid) 87.5MHz check 1.6V ±0.5V
2108 C1 2123 C3 2132 C4 2140 B4 2148 A5 2164 B5 3105 B2 3132 B3 3145 C4 3154 B5 3160 A3 3171 B5 3192 A2 4104 C3 6107 B5 7111 A4
2109 C1 2124 C3 2134 C5 2141 B5 2149 C4 2165 B3 3108 C2 3134 C3 3146 B5 3155 B5 3161 A4 3172 B5 3193 B2 4105 B2 6120 A4 7122 C3
MW 8V ±0.2V 3-band
2118 C3 2125 C3 2135 C5 2143 B5 2150 B3 2166 B5 3109 C1 3137 C4 3150 A3 3156 A4 3167 A5 3176 C4 3194 B2 4106 B3 7101 B4 7124 C3 1602kHz 5123 6.9V ±0.2V 2-band
1101 B5 1110 B4 1131 C5 2107 B3 2133 C1 2162 A4 5103 C4 5111 A3 5115 C2 5122 C3 7105 C5 9102 B2 9105 B1 9108 B3 9111 A4 2119 C3 2127 C4 2136 A3 2145 A3 2159 B3 2167 B4 3123 A5 3141 B3 3151 A2 3157 A4 3168 C5 3180 A5 3195 B2 4107 C3 7103 C5 531 - 1602kHz 1
1102 B5 1120 A4 1132 A4 2128 B3 2138 B1 3142 C2 5109 A3 5112 A3 5119 B2 5123 C3 7112 B1 9103 A1 9106 B1 9109 C2 2120 C3 2130 B3 2137 A3 2146 B5 2161 A4 2169 A3 3125 A5 3143 C5 3152 A3 3158 A3 3169 B4 3190 B2 4101 C2 6105 B2 7109 A5 (9kHz grid) 531kHz check 1.1V ±0.4V
1103 C5 1130 A5 2106 B4 2129 B4 2144 B1 5102 C4 5110 A2 5114 A2 5121 B2 7104 C4 9101 A2 9104 B1 9107 B4 9110 A4 2122 C3 2131 C4 2139 B4 2147 A3 2163 A4 2190 B2 3128 C2 3144 A5 3153 A3 3159 A3 3170 A4 3191 A2 4102 C2 6106 B2 7110 B2
LW 279kHz 5122 8V ±0.2V
1 2 3 4 5 1 2 3 4 5 153 - 279kHz
(3kHz grid) 153kHz check 1.1V ±0.4V
TUNER BOARD ECO6 Systems - Cenelec / componentside view TUNER BOARD ECO6 Systems - Cenelec / copperside view
FM - IF
4 3
IC 7101 21
10.7MHz, 45mV
A 1 7 FM continuous wave D shortcircuit 2141
5119 2 0mV ±3mV
2 8 to block AFC
A A A 1 K
A FM - VCO
FM FRONTEND
FM 75Ω A 98MHz, 1mV
FM A 98MHz 3142 3 152kHz ±1kHz 1)
D C continuous wave
B B B A B E B FM RF (channel separation)
Note:The FM-frontend unit has already been adjusted by the factory
and needs therefore no further adjustments for service purposes.
Vdd SMD jumper
C 41.. 98MHz, 1mV
IF coil
AM FRAME AERIAL 8 inside
(not all items shown FM 90% Left + 9% pilot A 98MHz 4 right channel min.
in schematic diagram) FM frontend
mod=1kHz
Vcc2 1110
AM IF
C B C C Vcc1 C
IC 7101 36
Birdy Filter
C 100nF
5111
220R
max.
D f = ±10kHz
ECO6 Sys-Cenelec stage .2, 270899
MW 450kHz
VRF = 0.5mV IC 7101 40
5
ECO6 Sys-Cenelec stage .2, 270899
1 5 2 (as low as 100nF
1 2 3 4 5 connect pin 6 of 5112 fo
220R
possible) see symmetric
1 2 3 4 5 IC 7101 (AM Osc.) remark 2)
with 3.3kΩ to Vcc
These assembly drawings show a summary of all possible versions. AM AFC C
For components used in a specific version see schematic diagram respectively partslist. 5114 2 0mV ±2mV
MW continuous wave
VRF = 2mV
AM RF 3)
1494kHz 1494kHz 2106

B
MW
max.
558kHz 558kHz 5102 5
D f = ±30kHz
fo
LW 198kHz VRF as low as 198kHz 5103 symmetric
possible
ECO6 Sys Cenelec, 190599
Use Service Testprogram. By selecting the TUNER TEST test frequencies will be stored as preset frequencies automatically.
1) If sensitivity of frequency counter is too low adjust to max. channel separation
(input signal: stereo left 90% + 9%, adjust output on right channel to minimum)
2) RC network serves for damping the IF-filter while adjusting the other one.
3) For AM RF adjustments the original frame antenna has to be used!
MW has to be aligned before LW.
Repeat
PCS 99 478
8-3 8-3 8-3
TUNER BOARD ECO6 (Non Cenelec) - LAYOUT DIAGRAM TUNER ADJUSTMENT TABLE ( ECO6 FM/MW- and FM/MW/LW - versions with AM-frame aerial )
Waverange Input frequency Input Tuned to Adjust Output Scope/Voltmeter
VARICAP ALIGNMENT
2101 B5 2125 D3 2134 D7 2141 C6 2149 D6 2161 A6 2169 A4 3132 D5 3146 C7 3157 A6 3168 C7 4103 B5 6106 C3 7102 D4
2103 D4 2126 D6 2135 D7 2143 C7 2150 B5 2163 B6 3101 D5 3134 D3 3152 A4 3158 A4 3169 B6 4106 C4 6107 C7 7103 D7 FM 108MHz 5130 8V ±0.2V
2104 B4 2127 C5 2136 A4 2145 A5 2152 C5 2164 C6 3102 C3 3141 C5 3153 A4 3159 A5 3170 A6 4107 C5 6120 A6 7111 A5 87.5 - 108MHz
1101 A6 1120 A4 1132 A5 2128 C4 2138 C2 3142 D2 5110 B3 5114 A2 5123 D5 7112 C1 9104 B5 9107 D4 2119 D3 2130 D5 2137 A4 2146 B7 2153 C5 2165 C4 3103 C4 3143 D6 3154 C7 3160 A5 3172 C7 4108 C5 6130 D4
(65.81 - 74, 87.5 - 108MHz) 87.5MHz check 4.3V ±0.5V
1102 B6 1130 B5 2106 C5 2129 B4 2144 B2 5102 D6 5111 B4 5119 C2 5130 D3 9101 A2 9105 B1 9108 C4 2120 D3 2131 C5 2139 C6 2147 A5 2154 C4 2166 B6 3104 B4 3144 B7 3155 C7 3161 A5 3176 D6 6103 B3 6131 C4 (65.81MHz) (1.2V ±0.5V)
1103 D6 1131 D5 2107 B5 2133 D2 2155 C4 5109 A3 5112 A3 5121 B2 5131 D4 9103 B2 9106 B3 9109 D2 2124 D3 2132 D6 2140 C6 2148 B6 2159 C5 2167 B6 3105 C4 3145 C5 3156 A6 3167 B7 3181 D4 6105 C3 7101 C5
MW 1700kHz 5123 8V ±0.2V
FM/AM-version, 10kHz grid
530 - 1700kHz 530kHz check 1.1V ±0.4V
1 2 3 4 5 6 7 2 3 4 5 6 7
FM/MW-version, 9kHz grid 1602kHz 5123 6.9V ±0.2V
TUNER BOARD ECO6 Systems non Cenelec / componentside view TUNER BOARD ECO6 Systems - non Cenelec / copperside view 531 - 1602kHz 531kHz check 1 1.1V ±0.4V
4 3 LW 279kHz 5122 8V ±0.2V

A A A
A 1 7 A 153 - 279kHz 153kHz check 1.1V ±0.4V
2 8
K MW 1602kHz 5123 8V ±0.2V
FM/MW/LW- version, 9kHz grid
531 - 1602kHz 531kHz check 1.1V ±0.4V
A
B FM 75Ω B B C B
FM IF
IC 7101 21
C Vdd 10.7MHz, 45mV
B E FM
continuous wave
D shortcircuit 2141
5119 2 0 ± 3 mV DC
to block AFC
A SMD jumper
41.. FM RF
C C C 1 (not all items shown C
AM FRAME AERIAL in schematic diagram)
FM 108MHz A 108MHz 2155
87.5 - 108MHz 4 MAX
Vcc2 2 (65.81 - 74, 87.5 - 108MHz) 87.5MHz mod=1kHz 87.5MHz 5131
(65.81MHz) D f=±22.5kHz (65.81MHz)
D B D VCO
D D
98MHz, 1mV
Vcc1 FM
continuous wave
A 98MHz 3142 3 152kHz ±1kHz 1)
ECO6 System non Cenelec stage .2, 211099
1 2 3 4 5 6 7 D 5 ECO6 Systems non CENELEC stage .2, 211099

AM IF
2 3 4 5 6 7 IC 7101 36
100nF
C 5111
220R
These assembly drawings show a summary of all possible versions.
max.
For components used in a specific version see schematic diagram respectively partslist. MW 450kHz D f=±10kHz IC 7101 40
5
VRF = 0.5mV 100nF
connect pin 6 of 5112
220R
(as low as see fo
IC 7101 (AM Osc.) possible) remark 2) symmetric
with 3.3kΩ to Vcc

AM AFC
C
5114 2 0 ± 2 mV DC
MW continuous wave
VRF = 2mV
AM RF 3)
MW 4) 1494kHz 1494kHz 2106
FM/MW/LW- and FM/MW-version B
( 9kHz grid)
531 - 1602kHz 558kHz 558kHz 5102
max.
LW 198kHz 198kHz 5103 5
MW 1500kHz D f = ±30kHz 1500kHz 2106 fo
symmetric
FM/AM-version, 10kHz grid VRF as low as
530 - 1700kHz 560kHz possible 560kHz 5102
ECO6, Sys + PA with frame aerial, 070799
Use Service Testprogram. By selecting the TUNER TEST test frequencies will be stored as preset frequencies automatically.
1) If sensitivity of frequency counter is too low adjust to max. channel separation 2) RC network serves for damping the IF-filter while adjusting the other one.
(input signal: stereo left 90% + 9%, adjust output on right channel to minimum)
3) For AM RF adjustments the original frame antenna has to be used ! 4) MW has to be aligned before LW.
Repeat
PCS 104 194
8-4 8-4
TUNER BOARD ECO6 (Non Cenelec) - CIRCUIT DIAGRAM
1 2 3 4 5 6 7 8 9 10 11 12 13 14 1101 A1
1102 B1
1103 F2
1120 E14
1130 A2
TUNER BOARD ECO6 / SYSTEMS NON CENELEC 1131 B1
1132 G13
2101 B3
1101USA 2103 C7
2104 B3
3
1130 2106 F3
2107 F4
2
C-PAD VERSION PROGRAMMING COMPONETS 2119 H6
AM-IF1 2120 G6
1
5111 450kHz
A YKD21 4 3 VERSION A 2124 H6
2125 H6
6120 3156 3157 3170 7111 2126 F7
T113
2 2127 E7
A FM 75 OHM
1
2150 AM-IF2
5112 450kHz
/00 /02 FM/MW/LW 2128 B8
2129 C7
6 /00 /02 FM/MW
100n 2130 F11
8 7 3 4
/01 FM/MW 2131 G8
not USA T115 T114 2132 G8
1102 2
/14 FM-OIRT/MW 2133 G8
1
2104 1 2134 H8
6 /17 FM/AM 2135 H9
T102 100p 2136 G14
7P 7 8
2 6103 component mounted
2101
B B 2137 G13
47p
BAV99 printed
FM-IF1 FM-IF2 2138 F9
330R
3104
1131 T103 5109 5110
C 2128 I 1 O 3 I 1 O 3 AM-AFC
2139 G9
2140 G9
2141 F10
C-PAD 5114 450kHz VERSION DETECTION 2143 G12
0.7V 1.1V
3105 T109 G 2 G 2
10u 3 4
2144 G11
2145 F12
1.4V
0.2V
0.8V
1.4V
1.4V
1.4V
0.7V
6120
1.4V
220R 2146 E12
BAS216
1V
2
7101 P1
6106
2147 E12
FM-RF TEA5757H 44 43 42 41 40 39 38 37 36 35 34 BAS216
3103
8K2
1 2148 E12
2165
3156
6 0.2V 2149 H7
AM-MIXOUT
FM-MIXOUT
100K
FM-IF2
VSTABB
AGC
FM-IN
RF-GND2
AM-IF1-IN
FM-IF1-IN
AM-IF2
VSTABA
7 8 2150 A10
0.6V 100n 7P
C Q-multiplier 2129
AM DET
1.2V 7111
BC847C
C 2152 E4
2153 E5
2V 0.7V
OUTPUT PORTS
7102 1 RIPPLE AM-IF FM-IF2-IN 33
2154 D5
BF550 100u AGC P1 2155 D5
100K
0V
3170
3157
100K
PROGR.
FM 2159 F6
2103
2161 p
AM AM
1n
0V 2 IF1 32 2161 C11
0V AM-RF AM-AFC
100n
FRONTEND MIXER
5131 2163 D11
1.4V
CTRL 2164 F10
T128 P0
6131
3 FM-RF P1 31 7.9V 2165 C7
1SV228
AM FM
p
AM AGC
IF IF2 2166 E11
2163
100n
OSC 2167 E11
printed
p
3102 4 RF-GND1 FM P0 30 7.7V 2169 H8
CONTROL
D
2154
2155
11p
FRONTEND
4p7
FM 0.1V 3101 E4
D 100K 0.1V 5 FM-OSC FM
MIXER
AGC
CONTROL WRITE-EN 29 0V 3161 D 3102 D4
3103 C6
printed OSC PRE- MULTI-
22K 3104 B8
SCALER PLEXER
28 0V 3160 3105 B6
0V 6 AM-OSC
AGC
DATA
3132 G5
RIPPLE VSTABA VSTABB 3134 H6
470R
VCC1 7.6V 7 VCC1 VDD CLOCK 27 0V 3159 3141 E7
FM-OSCILLATOR 7.8V STABILIZER 152kHz, 50mVpp 3142 E7
AGC AM 3169 2166 470R 5V
3143 G7
1SV228
6130
220p
I-TUNE
2148
2146
1.6-8V 8 DET DIG-GND 26
2n2
CHARGE 3144 H7
150K
220p
1n
2147
3142 1-8V PUMP 3145 F8
VCO 3141 FM 5121 2167 0V 3146 G13
1V 9 VCO XTAL 25 1.4V stereo mono stereo 3152 G14
3101 DET
2153
E E
3181
5130
15p
1.3V VCC2 3153 G13
1K
OSC 12p
56K DT-381 75KkHz
33K 100K
0.7V 10 AF-OUT MONO/ 24 stereo 0.2V 3 stereo 0.4V
3154 G13
3155 G11
2152
33n
STEREO mono 4.8V mono 4.8V 3156 C12

2127 23 1120 3157 C12
11 MPX-IN STEREO VDD
9.6V 3158 T123 3158 E13
FIELDSTR-IND
1.2V AFC STEREO 8
220n DECODER VCC2 3159 D13
FM-DEMOD
AM-RF 9.5V
1 470R
330p
T122
2126
0V CLOCK 7 3160 D12
220p
IF-GND
2145
FILTER
RIGHT
3161 D13
PILOT
MUTE
6105-1
AFC+
2
LEFT
AFC-
MW 0V T121
LPF
AM FRAME AERIAL VDD DATA 6 3167 F12
T111 3168 F11
1103 5102 8 1 T120 ENABLE/MPX 5
to/from
7 7KL
HN1V02H 7 12 13 14 15 16 17 18 19 20 21 22 MPX 0V 3169 E11
11.1V
2 T105
0.15V
0.8V
0.6V
0.6V
0.8V
1V
6 1
T142 1.1V
T141 1.1V
2V
3170 C12
7.6V T140 3168 3167 from 2169
1V
0V
2u2 1.2V
T127
2107
F 12Vtyp VCC 4
F
1u
3172 G12
1 T106 T110 VCC1
2106
5
11p
2 7.8V 120R 120R (10-14V) 3176 G7

T126
2141 T116
2138
RIGHT 3
VCC2 3181 E6
2130
22n
2159
XH-S T125
33p
3145
5102 F2
2K2
4 3 GND 2
100n
5109 B9
1132
C-PAD
LEFT 1 5110 B10
5
T112
AM-OSCILLATOR 2164
470n
2131
470n 2133
5111 A9
1u
11.1V T117 3154
5112 A11
470n VCC2 FE-BT-VK-N
3 6 11.1V 5114 B11
330R
2132
BZX284-C11
2139
5119 G9
15p
6105-2
3172
5K6
B
HN1V02H
T124 5121 E11
6107
6105
MW
5119
2 12V
4 5123 G5
5130 E5
470R
470R
5123
3153
3152
4 3
G RDS only 7112
G 5131 C6
3132
1 8
47R
4 3 BC547C 9.6V
2140
82p
2 6103 B3
VCC1 3155
2 7 9.6V T118 6105-1 F3
2120
18p
2
VDD
220n
1
22R
6105-2 G5
2143
3146
3 6 6 9.5V 220R 10.4V
220n
220n
3143
2136
22K
3176
6106 C3
33K
2137
1
2144
6 8 7 6107 G13
1u
4 5 6120 C13
8 7
p
HN1V02H MPX 6130 E5

3144 2169 DISCRIMINATOR
560p
3134
2119
2125
22K
10p
1.3V 6131 D5
1K 2n2 to 1120 7101 C8
0.7V pin 5 7102 C6
7103 7103 H7
BC857C 7111 C13
H H 7112 G12
2124
2149
22n
33p
MPX T102 B2
T103 B2
22n USA
22n USA
BUFFER AMPLIFIER T105 F2
2134
2135
T106 F2
15n
15n
T109 B6
T110 F5
T111 F4
T112 F7
T113 A9
T114 B10
ECO6 Sys-non Cenelec, 991102
T115 B9
T116 F10
T117 G13
1 2 3 4 5 6 7 8 9 10 11 12 13 14 T118 G11
T120 F13
T121 F13
...V FM mode stereo
LEGEND T122 F13
T123 E13
p ...for provision only ...V MW mode T124 G14
USA ... for USA version only V EVM ...V LW mode
voltages measured while
set is tuned to a strong transmitter
PCS 104 195

9-1 9-1
POWER BOARD - CIRCUIT DIAGRAM POWER BOARD - LAYOUT DIAGRAM
0013 C4 1600 C2 1603 D3 3600 B2 3603 C4 5602 E2 6600 A3 6603 A3 7600 C3 9603 C2
0014 C4 1601 C3 1604 B3 3601 A4 5600 A1 5603 A2 6601 A3 6604 A4 9601 D4 9604 A2
0015 A4 1602 D3 2600 B3 3602 B4 5601 C2 5604 F2 6602 A3 6605 B4 9602 D3
1 2 3 4
AC1a
NEUTRAL
3601 6604
1 2 3 4 5 6 7 8 9
4K7 1N4148 0015
6600 6601 DIPMATE
5600 1
PWRDWN
1
A TO
1 8 4
5603
1N4148 1N4148 A A A
MAINS 9604 2
+C
EI-28-12.3
CABLE 4 5 3
3 6 6602 6603 GND_D
Mains
filter 4
STANDBY
1N4148 1N4148
2600 B B
220u to AF board
LIVE conn. 1252
AC1b
3600
B 10M 3602 B C C
10R
AC1a 1604
/37 ONLY 2 3
6605
to chassis 1N4148 D D
4
1
AC1b
120V 230V 7600 3603
BC547B 10K
4 5 6
E E
C 1600 /21 only 9603 FORESEEN ONLY C
1 2 3 /22 & /37 only
1601
5601
0014 0013 1 2 3 4 5 6 7 8 9
T 3.15A DIPMATE DIPMATE
EI-57-30 1 1
1 7 1602
9 2 2
3
10 MC148- T2A 3 3
9602 MC118- T 3.15A
D 5 12 MC20 only 4 D
MC20 only
9601
13 MC20 only MC10 only
6 16
MC10 /ALL to AF board
1603 conn. 1250 & 1251
5602
T 3.15A
EI-57-35 MC10 only
1 7
10
3
12
E 5
16 E
6
MC20 /02 & /17
5604
EI-66-40
1 8
12
3
F 13 F
17
5
6
MC20 /01
1 2 3 4
PCS 104 569

10-1 10-1
LED BOARD - CIRCUIT DIAGRAM LED BOARD - LAYOUT DIAGRAM
3901 C1 6903 B1 6909 B2

3902 C2 6904 A2 6910 A3 1 2
3903 C3 6905 B2 6911 B3
3904 C3 6906 B2 6912 B3
6901 A1 6907 A2 8901A B1
6902 B1 6908 B2 8901B B1
A A
1 2 3
B B
A 6901
LTL-16KGE
6904
LTL-16KGE
6907
LTL-16KGE
6910
LTL-16KGE
A C C
8901A
6902
LTL-16KGE
6905
LTL-16KGE
6908
LTL-16KGE
6911
LTL-16KGE
D D
B To Front Board B
8901B
6903 6906 6909 6912 E E
LTL-16KGE LTL-16KGE LTL-16KGE LTL-16KGE
3901 3902 3904

F F
C 120R 120R
3903
120R 120R C
G G
1 2 3
1 2
PCS 99 480
11-1 11-1
RECORDER BOARD ETF6 (Servo) - CIRCUIT DIAGRAM
1703 B1 1770 B7 2623 D2 3601 B2 3604 C2 3607 C6 3610 D6 3613 B2 3618 A4 3623 A3 3626 B6 3672 B4 3678 B5 3685 C2 3688 A5 4784 A1 6611 A2 7610 D4 7614 A6 7619 B4 7623 C2
1706 E1 2621 D2 2624 E2 3602 C2 3605 B3 3608 D6 3611 C6 3614 B6 3620 A4 3624 B6 3628 A5 3674 A5 3679 B3 3686 E6 3689 E3 4785 D2 6612 B6 7612 A6 7616 A4 7620 B6 7624 D6
1760 B8 2622 D2 2625 E4 3603 B2 3606 C3 3609 C6 3612 D6 3616 A5 3622 A4 3625 B3 3630 A6 3676 B5 3680 B5 3687 D2 4781 A5 4795 E3 6614 B4 7613 A3 7618 B6 7622 B5
1 2 3 4 5 6 7 8 9
DECK AB SERVO CONTROL
+MOTOR 7612
13
PHOTO_A
CCTRY
SOL_A
BC807-25 12
3618
3616
10K
10K
CR02_A
11
L L H
# 4784
10 SINGLE
A A
100K
3628
3620
# 3622
+MOTOR L
L 7613 9
DECK
4K7
4K7
3688 #
M Gnd
M BC807-25 L
680R
470R
4781
SOL_A 3630 8 8
mode_B
1N4003
PHOTO_A 7616 L L 470R +MOTOR 7614 7 7

6611
BC857B Vcc
CR02_A
L BC807-25 6 6
100K
3623
sol_B
L 3674
5 5
photo_B
1N4003
+MOTOR M L 3625 4K7
6612
4 4
CrO2_B
100K
3624
1N4148
1K
6614
7618 3 3
+5 HS
7619 L BC847B Rec_FWD
2 3672 L M
BC847B L 2 2
B 1
3613 +5
4K7 M
3626
+5
Rec_RVS B
3678
7622
47K
M 27K M 1K 1 1
Rec_RVS
3679
47K
1703 BC847B 1770 1760
7620
3601
3603
3605
2K2
2K2
2K2
M BC847B
L
3614
3676
27K
47K
3680
47K
Rec_RVS M
M +5 VARIANT TABLE
CRA
P Ref Des ND/DD/FR ND/DD/FF ND/SD
3602
3604
3606
120K
27K
56K
3611
3609
3607
2K2
2K2
2K2
C 8
VSS
P
--
C
10 7
Os' O3
9 11 CRB
7623 Os O7
BC847B 3685 1 13
2A2
STR O5
100K
120K
3612
3610
3608
7610
56K
27K
HEF4094BT 12
2 O6
P D
2623
2622
2621
470p
470p
14
1n
O4 7624
D #
3687 3 4
BC847B
D
CP O0
100R REC
5
O1 1A0
4785
STROBE 7
6
DATA 6 O2
VDD E0
CLK 5
100K
3686
16 15
GND_P 4
2624 2625 2A1 * See Variant Table for details
M
P 100n P 100n # For Provision Only
+5 3 +5 L Not For Single Deck Variant
E AD1 2
+5
E
AD2 1 ** Items used for pcb testing only
1706 **
4795 Version 3689 4795
TO/FROM FRONT
3689
1. ND / DD / FR - -
4K7
2. ND / DD / FF - use
3. ND / SD use -
3139 118 51470 sh 130-1 dd wk901
1 2 3 4 5 6 7 8 9
PCS 104 196

11-2 11-2
TAPE MECHANISM ELECTRONICS TAPE ADJUSTMENT & CHECK TABLE
TEST RECORDER MEASURE ADJUST
READ ON
CASSETTE MODE ON with to
+ ADJUST MOTOR SPEED

Motor
-
SBC420 PLAY B 1 or 2 3620 3150Hz ± 0.5%
NORMAL SPEED frequency
3150Hz PLAY A counter check
LEFT RIGHT 3150Hz -0.8/+1.8%
NC
Photo Sensor NC CHECK WOW & FLUTTER
8. Gnd SBC420 1 or 2
DECK A & B PLAY W&F-meter check ≤0.4 % DIN
7. Mode SW 3150Hz
LEFT RIGHT
Mode 6. Vcc 12V
ADJUST AZIMUTH
5. Sol.
SBC420 PLAY FWD 1 or 2 left hand screw max. output level
CrO2 4. Photo Out mV-meter
DECK A & B 10kHz & left=right
3. CrO2 SW PLAY REV # LEFT RIGHT right hand screw
R1 = 680R
2. Rec SW Forward CHECK PLAYBACK FREQUENCY RESPONSE
Rec-F 1. Rec SW Reverse

1 or 2
DECK A & B SBC420 PLAY mV-meter check limits see fig.1
LEFT RIGHT
Rec/Pb Head wire Rec-R
Head connector pcb ADJUST BIAS CURRENT
1. +L ch (White) 3773
2. Earth (Black) SBC419A 5 or 6 995mV
DECK B RECORD mV-meter
3. +R ch (Red) SBC420
Solenoid LEFT RIGHT check 750mV ± 1.5dB
4. E Head (Blue)
5. E Head (Yellow)
CHECK OVERALL FREQUENCY RESPONSE AND DISTORTION
Inject 3mV signals
100Hz, 250Hz, 1kHz, SBC419A
10kHz, 12.5kHz or RECORD B
TAPE DECK WIRING SBC420
via 3 or 4
TO ETF6-FE BOARD 1760

RECORDED 1 or 2
REC REC PLAY B mV-meter check limits see fig. 2 *
REV FWD
CASSETTE
LEFT RIGHT
CRO2
Inject 1kHz 8.85mV SBC419A
or RECORD B
via 3 or 4
SBC420
RECORDED 1 or 2
PLAY B THD-meter check ≤3% *
CASSETTE
LEFT RIGHT
Solenoid SBC419A : 4822 397 30069 # For Auto-reverse version only
SBC420 : 4822 397 30071 * If high frequencies are not within limits, decrease bias and re-measure.
MODE If distortion is too high, increase bias and re-meaure
SW
TAPE DECK +_ Variation table for Analog Circuit
MOTOR level(dB) level(dB)
Item No. Autoreverse (FR) Non-Autoreverse (FF)
3723 12k 15k
3724 12k 15k
3743 1k2 1k 8dB 6dB 8dB 8dB 6dB 8dB
10dB (HSD) 10dB (HSD)
3744 1k2 1k
3769 12k 8k2
TO ETF6-FE BOARD 3772 4k7 5k6
CONNECTOR 1710 3774 10k 8k2 f(Hz) f(Hz)
80 250 4k 12.5k 100 250 4k 10k
figure. 1 figure. 2
PCS 104 197

11-3 11-3
RECORDER BOARD ETF6 (Analog) - CIRCUIT DIAGRAM
1 2 3 4 5 6 7 8 9 1701 F9
1710 C1
3716 B6
3717 C6
5703 F1
6770 E2
1730 A1 3718 D6 6771 E2
2727 2701 B2 3719 C6 6772 D1
3735 1n 3711 2713 3741 2702 B2 3720 D6 6773 D1
REC_L B1
2703 A2 3721 C6 6774 D3
22K 3723 150K 3763 10u 2K2
3733
2703
100p
1K
2733 9793 3727 2729 2704 B2 3722 D6 6775 C3
PLAY BACK * 12K LEFT CHANNEL 3705 12150K 5 LH
9791 A 2705 A2 3723 A3 6776 F3
3
DECK A A A 470p 5K6 27n B3
2706 A2 3724 D5 6777 E2
PC2 PC1
L 220R 3713 3731
2707
470p
1730 7710 MODE 7740
A 1
3703 L HEF4952B SELECTOR
10
IN2 2711 HEF4952B P A 2707 A4 3725 C5 6778 E4
1N4148
10R 6K8
2709
3715
330p
2708 B4 3726 D5 6782 C7
6785
A
1K8
15 13
220R 2705 A0 7 1A0 OUT2 100p
15 A0 7 2A0
220p
2 16 S0 +C A 2715 2709 A5 3727 A7 6785 A7
A A1 9 1A1 3707 3729 16 S0 A1 9 2A1 M
14 S1 11
3 L A2 10 NF2 2737 A 3760 14 S1 A2 10 2A2 2710 B5 3728 B7 6786 B7
12 S2 14 12 S2
220u 100R AN2 2K7
3709
A 2711 A6 3729 A7 7710 A3
6R8
11 S3 8 11 S3 8
S4 -C 3764 100n 120R S4
2706
2744
220p
100n
16 7720 A 2712 B6 3730 B7 7720 A5
L VSS +12 Vcc VSS
3767
ALCEN
4M7
2 2
4 3704 L VEE 4 220R AN7318S ALCC 3732 2 VEE 4 -C 2713 A6 3731 A7 7730 D6
2761
220u
1N4148
1 S0 A 1 S0
3765
2735
100n
A
6786
3 S1 2714 B6 3732 A7 7740 A8
220R VDD 13 PB/REC 6K8 3 S1 VDD 13 +C PLAYBACK
2765
1
47u
3736 5 S2 GND AMPLIFIER 39K 3730 5 S2 2715 A4 3733 A2 7780 F4
3734
2704
3766
100p
2762
2763
4M7
EQUALISATION
4u7
47u
6 S3 6 S3
1K
REC_R S4
A RIGHT A 15 3
S4 2716 C4 3734 B2 7781 F3
22K CHANNEL A RF AIN1 2K7 2717 C6 3735 A2 7782 E1
A A 3706 7 3728 2730 9792
IN1 2738 A B4 2718 D6 3736 B1 7783 E2
2708
3716
470p
B B
1K8
220R 5K6 27n 2719 C5 3741 A6 7784 D2
2702
2710
150p
330p
A2 A1 A0 S0 S1 S2 S3 S4 4
OUT1 100n 3714
2701
150p
STOP 0 0 0 1 1 2720 D5 3742 B7 7785 C3

Pb deck A 0 0 1 1 1 A 3708 6 A2 A1 A0 S0 S1 S2 S3 S4
3701 Pb deck B 0 1 0 1 1 NF1 10R 2721 C5 3743 F8 7786 C2
-- 0 0 0 1 1
-- 0 1 1 1 1 1 100R 2722 D5 3744 F8 7787 C8
2712
100p
2714
5 NC1 NC2
10u
REC in 1 0 0 1 1 STOP 0 0 1 1 1
220R 3712 8 9 2723 C5 3745 F8 7791 F5
Dubbing 1 0 1 1 1 -- 0 1 0 1 1
3702 3742
3788
REC/PB -- A
1M
1 1 0 1 1
DECK B -- 1 1 1 1 150K A B2 REC 0 1 1 1 1 1 2724 D5 3746 E8 7792 D8
1710 220R 2734 2K2 ALCEN
HS Chrome 1 0 0 1 1 2725 D4 3748 C8 9791 A8
1 Pb Chrome 1 0 1 1 1
6775 -- 2726 D4 3749 C7 9792 B8
470p 1 1 0 1 1
2716
220u
2 #100K 2719 3721 2717 LH 6782 Pb Ferro 1 1 1 1 2727 A3 3751 E5 9793 A6
1A0 2728 D5 3752 F5
1N4148
3785 BIAS 33n 5K6 10n 3748
4790
C 3
SYMM 3787 3719 3717
1N4148 7787
C 2729 A8 3753 F5
3710
6R8
3749 2K2 BC847B 2730 B8 3754 E8
3782
4794
15K
4
#
1M 2721 3725 4K7 2K2 REC

# 7785 A 2733 A5 3755 E7
A 47K
5 # J111 10R 15 A0 7 3A0 2734 C4 3756 D8
A 6n8
2742
6 7786 +5
22n
5702 2723 16 S0 A1 9 REC 2735 B3 3757 D8

A J111 B1 14 S1 A2 10
12 S2
CRB CONTROL LOGIC 2737 A6 3758 D8
2u2 15n 2741
2725
3759
10K
4n7
3784 A A 11 S3 S4 8 2738 B6 3759 D7
PB SWITCH P P
A VSS A 22n 7792 3756 2741 D6 3760 A7
2722 2 VEE 4
1K 3781 A 3726 -C BC847B CRA 2742 C3 3761 E3
1 S0
-C 2A0 220K
BC857B
3 S1 VDD 13 2743 F1 3762 E2

4M7 3779 6n8 10R +C 3757
5701
2u2
2724 5 S2
7784
HS 2744 A3 3763 A5
D 2786
6773
3780 330K REC B2 6 S3 S4 7730
HEF4952B
220K D 2760 E3 3764 A5
2726
6774 15n P
4n7
100p 1M 2761 B5 3765 B6

2787
3758
10K
33n
1N4148 * 3724 2720 3722 2718 2762 B6 3766 B7

1N4148
6772
1N4148 A 2763 B6 3767 A7

A A 12K 33n 5K6 10n
+C 2728 3720 3718 P 2765 B4 3768 E8
+12
A 2769 F7 3769 E4
3762 3761 1n 4K7 2K2 3754 2770 F7 3770 F2
3A0 HS
1N4148 1N4148
820R * 10K 1M 2780 F3 3771 F2

2760
100n
6770
BZX79-F8V2
REC EQUALISATION A2 A1 A0 S0 S1 S2 S3 S4
3774
3755
2781 F2 3772 F3
8K2
1M
NS Ferro 0 0 0 1 1 1 2
3778
6777
6R8
HS Ferro 0 0 1 1 1 2782 F2 3773 E3

E A *
3769
6778
+5 REC MUTE 0 1 0 1 1 E 2784 F1 3774 E3
6771
BIAS REC MUTE 0 1 1 1 1 1

LEVEL CRB M 3768 2785 F1 3775 F2
12K NS Chrome 1 0 0 1 1 -C 7 -CMOS
BC557B P 1N4148
3773
+12 HS Chrome 1 0 1 1 1 3746 10K 2786 D1 3776 F2

7782 REC MUTE 1 1 0 1 1 B4 TAPE-R 2787 D3 3777 F2
3751
P 7783 6
10K
4K7
12V
-- 1 1 1 1 3K3 +12 3701 B1 3778 E1
BC847B +12V
3789
MT1 7 MT2 5
8
47K
3770 3771 1A1 3745 3702 B2 3779 D3

3 6 6776
3752 B3 TAPE-L 3703 A2 3780 D2
3772
P 7791 4
4K7
5 1K5 1K2 3K3 3704 A1 3781 D2

2 100K BC847B
3744
3743
A 3 GND_A
2769
470p
2770
470p
1N4148
1K2
1K2
2782 * 3705 A4 3782 C2
1 4 P 7780 3786
3777 P REC_R 3706 B4 3784 D1
100K
3753
7781 2 REC-R
BC847B 22K L Not For Single Deck Variant * *
4n7
F F
2780
3707 A5 3785 C2
22u
CLNS-2A833 YEZ BC817-25 REC

150R 3776 A A A A REC_L 1 REC-L
5703 * See Variant Table for details 3708 B4 3786 F4
6K8
2781
3709 A4 3787 C3
3775
2785
2784
4R7
10n
# For Provision Only 1701

15n
1u
2743 P P
ERASE 1A0 3710 C4 3788 C3
TO/FROM AF
22n 3711 A5 3789 F3
A P OSCILLATOR
A A P P P 4 3 3712 B4 4790 C2
3713 A7 4794 C6
ANALOG CCTR 3714 B7 5701 D2
3139 118 51470 sh 130-2 dd wk901 3715 A6 5702 C2
1 2 3 4 5 6 7 8 9
PCS 104 198

11-4 11-4
RECORDER BOARD ETF6 - LAYOUT DIAGRAM
4 2 2 4
3 1 1 3
5 6 6 5
PCS 104 199

12-1 12-1
CD99 DA11 - LAYOUT DIAGRAM
1 2 3 4 5 1 2 3 4 5
1800 F2 3703 B5 3876 F4
CD99 Board component side view 1801
1810
A5
D3
3704
3705
A2
A3
3877
3878
F4
F4
CD99 Board copper side view
1821 E5 3728 E5 3879 F5
1822 A2 3745 B3 3880 F5
2840 5802 1823 G5 3750 B2 3881 E5
1824 D5 3751 B2 3882 F4
1
3 1
9
2701 B4 3757 B3 3883 F3
1822
8 7 2702 A2 3788 C5 3884 E3
A A A A
6
2703 A2 3800 F1 3885 B5

4 6
3
2704 A2 3801 G2 3886 C5
2801 F1 3802 G2 3887 B5
7809
1801
2802 E1 3803 G1 3888 C5

3863
2803 D2 3804 G1 3889 D5

2804 D2 3805 G1 3890 D2
2805 D2 3806 G1 3891 E2
2806 E1 3807 F1 3892 D2
1
2807 D2 3808 F2 3893 D2

B B B B
3750
3751
16
2808 D2 3809 F1 3894 E3

2809 D1 3810 E1 3895 E2
2810 C1 3811 D1 3896 E2
2811 C2 3812 D1 3897 D2
2812 C1 3813 D2 3898 D2
2813 C2 3814 D1 3899 D2
2814 D2 3815 D1 3900 D4
2815 C2 3816 D1 4801 E5
2816 C2 3817 C2 4802 F2
C C 2817
2818
D2
D2
3818
3819
C1
D1
4804
4805
D4
E4
C C
2842 2819 E4 3820 C1 4806 D5
2820 E3 3821 C1 4807 E2
2821 D4 3822 C1 4808 D5
1
2
2822 D4 3823 C2 4809 D5

1824
2817 2823 E4 3824 C2 4810 B2

2824 D4 3825 C2 4812 B4
5
2825 D4 3826 D3 4813 B3

6
D D 2826
2827
F5
C5
3827
3828
D2
E4
4814
4815
B3
A4 D D
2828 C4 3829 D5 4823 C2
1810 2829 A4 3830 D4 4824 B2
2830 B3 3831 F5 4828 B2
1 3 2831 B3 3832 F5 4831 B3
1821
2823
2832 B2 3834 D5 4832 B3

2833 H4 3835 C4 4838 C5
2834 B2 3836 C5 4845 D2
E E E E
3810
2835 H3 3837 C4 4847 E1

2857
2 14 2802 2836 G5 3838 C4 4848 B4

5803
2837 B2 3839 C4 4850 G5

1 1800 15 2838 B5 3840 B4 4853 F2
2839 A5 3841 B4 4856 F5
2840 A4 3842 A3 4857 B4
2846
2855
2841 E2 3843 A3 4859 B5

2801 2842 C1 3844 A3 4863 C5
2843 E4 3845 C3 4865 A4
F F 2844 E3 3846 A3 4866 B4

F F
2854
2845 E4 3847 B3 4872 F2

2846 E4 3848 B2 4877 H5
2847 F5 3849 H4 4881 G5
1
2851 2848 F4 3850 H4 4884 E2

2
1823
2849 F3 3851 B3 4885 G5

2850 F4 3852 B2 4886 G1
2851 G4 3853 H3 4888 F2
6
7
2852 F5 3854 H3 4889 G1
G 16 9
G 2853
2854
2855
E5
F3
E3
3855
3856
3857
G5
B3
B3
5802
5803
6877
A2
E5
F5
G G
3855 7808 2856 D5 3858 A5 7800 C4
2857 E5 3859 C2 7802 C2
1 8 2860 E3 3860 B2 7803 F1
2836
2861 E2 3861 B2 7804 G2

12-50-99 2862 E2 3862 B2 7807 D1 99-05-21
2863 D2 3863 A4 7808 G4
4.5143
3415.4
H H 2864
2865
2869
D2
D2
F1
3864
3865
3867
E1
E1
E4
7809
7810
7875
A5
F4
F5
H H
2870 E3 3868 E4 8401 H3
2871 E3 3869 E4 8402 H5
2872 E3 3870 F4
2873 D3 3871 E4
This assembly drawing shows a summary 2874 D3 3872 F5 This assembly drawing shows a summary
of all possible versions. 2875 D3 3873 E4 of all possible versions.
For components used in a specific version 3701 B4 3874 E4 For components used in a specific version
CD99 Layout stage .4 990817 3702 B4 3875 F3 CD99 Layout stage .4 990817
see schematic diagram respectively partslist. see schematic diagram respectively partslist.
1 2 3 4 5 1 2 3 4 5
PCS 99 483
12-2 12-2 12-2
CD99 DA11 - CIRCUIT DIAGRAM
1800 D1 2806 E4 2813 E9 2820 B10 2827 C14 2834 F5 2841 C1 2865 D5 2875 D5 3801 A1 3808 A2 3815 E5 3822 E7 3829 A11 3838 D14 3845 G12 3852 F5 3859 H5 3890 B4 3897 C5 7802-D E8 7808 E4
1801 G1 2807 E4 2814 E9 2821 B11 2828 C14 2835 F4 2842 F7 2869 E2 3728 A10 3802 B1 3809 A2 3816 E5 3823 E8 3830 B12 3839 D14 3846 F10 3853 F5 3860 H5 3891 C4 3898 C5 7802-E E7 7809 G4
2801 A2 2808 E4 2815 E10 2822 B11 2829 G14 2836 F4 2860 B5 2870 B5 3745 G12 3803 B1 3810 A3 3817 E7 3824 E9 3831 B14 3840 D15 3847 F6 3854 F5 3861 H5 3892 C4 3899 D5 7802-F F8 8401 H3
2802 A3 2809 E6 2816 F10 2823 B11 2830 F13 2837 G5 2861 B5 2871 B5 3750 G11 3804 B1 3811 E4 3818 E6 3825 E9 3832 B14 3841 E14 3848 F5 3855 F4 3862 H5 3893 D4 7800 D12 7803 B2
2803 E4 2810 E6 2817 D9 2824 B11 2831 G12 2838 G4 2862 C5 2872 C5 3751 G11 3805 A1 3812 D5 3819 E6 3826 D10 3834 B14 3842 G14 3849 E5 3856 G6 3863 H4 3894 A5 7802-A E6 7804-A A1 1821 D10 2702 E2 2845 A6 2850 B6 2855 D6 3703 D3 3867 A5 3872 A8 3877 C6 3882 D7 3887 E9 4805 C4 7810-A A5
2804 E4 2811 F7 2818 D9 2825 B12 2832 F5 2839 H4 2863 C5 2873 C5 3757 G5 3806 B2 3813 E5 3820 E7 3827 D9 3835 C14 3843 G14 3850 F5 3857 G5 3864 C1 3895 B5 7802-B E5 7804-B C3 1822 E4 2703 E4 2846 A7 2851 C7 2856 E10 3704 E4 3868 A5 3873 C5 3878 C7 3883 D6 3888 E9 4806 E9 7810-B C5
2805 E4 2812 E8 2819 B10 2826 A13 2833 F4 2840 H4 2864 D5 2874 D5 3800 B2 3807 A2 3814 E5 3821 E7 3828 A10 3837 C14 3844 G13 3851 F6 3858 G5 3865 F7 3896 B5 7802-C E5 7807 E6 1823 B10 2704 E3 2847 A8 2852 C8 2857 E6 3705 D3 3869 A6 3874 C5 3879 C8 3884 D6 3889 E10 5802 D3 7875 E7
1824 D10 2843 A5 2848 C5 2853 E6 3701 E1 3788 E9 3870 A6 3875 C5 3880 E7 3885 E8 3900 A5 5803 E6 8402 C9
2701 E2 2844 A5 2849 C5 2854 D6 3702 E2 3836 D10 3871 A7 3876 B6 3881 E7 3886 E8 4804 A4 6877 E7
1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 1 2 3 4 5 6 7 8 9 10
CD Part (sheet 1) +3.3V CD Part (sheet 2)

table for drive- and digital out recognition
DACLEFT_neg
DACRIGHT_neg
DACLEFT_pos
DACRIGHT_pos
2845
Vdd_HCU stuffed resistor drive digital out
3728 3828
+3.3V
3750 VAM on 220p
3810 47R 47R 2826 3751 VAM off 3869
2821
100n
+5V
A 3834 DA11 on
A
3805 27K
4R7 47n GNDA 10K

2801
3835 DA11 off

A 3900 A
3807 1K5
2,5V 4
3801
100R
3829
DACRIGHT_neg
150K
only for digital out versions D

3809 33R
3808 33R
GNDA 22K 2 3871 2846

5V
100p
2843
(Quartz used) 2,5V
47u
D
7804-A 3894 R2 (CD10) D 3867 1 470R
2802
3803 27K
3 8 +5V 10u
47u
0,2V LM358D 2,5V TDA 1308

DACRIGHT_pos
470p
2847
3870
3872
10K
47K
2823 3 8
1 2,5V 10K
0R 4804
2860
560p
2870
220p
22K
2844
7810-A
2819
2820
3831
220p
3868
33p
33p
22K
10K
3800 4R7
3830
5V
4K7
2 220u @ @ @
680R
3806
2822 2824 2825 D @ 3832 @

0,2V 4 3,9V HF DA 1810
4K7
3895 R1 (CD10) 1n5 47n 1n5 470R KILL GNDA GNDA GNDA GNDA GNDA
17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32
B B
3802
3,3V
1K
2861
2871
220p
10K +2.5V
1n5
TEST2
LN
LP
VNEG
VPOS
RN
RP
SELPLL
TEST1
CL16
DATA
WCLK
SCLK
EF
3804
VDDA2 KILL 1823

7803 1,8V 8.46 MHz
BC807-40 CRIN
D drive_recognition B 2850 basic version w/ 6p-connector B
TIMING
HF DA 16 VSSD1 33
LDON L Monitor L L SER. DATA 3834 22K @ 1
3890 3896 D4 (CD10)
+3.3V
CROUT BITSTREAM DAC VERSAT. 220p LEFT
LASER INTERFACE KILL
15 INTERF. V2|V3 34 2
GNDA
2862
180p
2872
220p
100K 10K 3835 22K 3876 GNDA
Laser power control D
VSSA2
D D GNDA 10K
3
RIGHT
14 WCLI 35
3873
DRIVE = DA11 2,5V 4 4
HF DA R2 SER. DATA DACLEFT_neg +5V
3891 3897 D 2827 1n digital out = off 6
D3 (CD10) LOOPBACK 22K 3878 2851 8402
100p
2848
13 SDI 36 2,5V 5
D GND
C 2863
INTERF.
C 7
180p
2873
220p
100K 10K R1 3874 2,5V 470R 10u 6
D 3837 470R DACLEFT_pos TDA 1308 +10V +10V
470p
2852
3877
3879
12 SCLI 37
10K
47K
3864 10K PORE 5 8
0R 4805
C 22K 7810-B C
+5V
220p
2849
3875
10K
D4 @ 5V KILL KILL
HF DA PRE- 2828 @ @
284147n 3892 3898 D2 (CD10) 11 PROCESSING SAA7325H RESETn 38 D FE-ST-VK-N
SANYO DA11 L D3
ADC 7800 47p
to
MICROCONTROLLER
SDA GNDA GNDA GNDA GNDA GNDA
2864
180p
2874
220p
1800 100K 10K 10 SDA 39
comm. cath 1 CONTROL AUDIO 3838 470R 1805
+2.5V
INTERFACE
D2 FUNCTION PROCESSOR on
B 2 SCL optical out coax out
HF DA 9 SCL 40 3839 470R sheet 2
2701 47p 22p 1821
F E 3 3893 3899 D1 (CD10) D1 (uP-interface)
2702 not stuffed 47n 1 doorswitch
D
D D 8 RAB 41 D 2703 Jumper 100n +3.3V
2865
2875
180p
220p
F 100K 10K +3.3V 2
+3.3V
+3.3V
+3.3V
4 3840 2704 not stuffed 100n GND
47n 2818 +2.5V
+5V
VRIN 5802 not stuffed stuffed
A C VREF GEN. SILD
D 5
L 7 SILD 42 470R D 3701 100R 270R 3884 3883 3882 100R
+3.3V EH-S D
3703 33R
B DA 27K 3826 3702 not stuffed 470R
3827
HF 3705 GNDA
33R
6 IREF
C HF-Amplifier
3836
3703 33R not stuffed 1K
2803 82p
2804 82p
82p
82p
1K
E 4K7 6 STATUS 43 3705 1R not stuffed
3885 10K
3886 10K
7 470K 3812
3887 10K
A 0,9V 0,9V BC847C HF 1R
3788
2854
220u
EFM 1824
4K7
2817 4u7 SRAM
10K
VDDA1 5802 2855
7807 DEMOD basic version w/ 5p-connector
2805
2806
8 2808 3813 3815 3817 ADDR D EH-S @

5 TEST3 44 from 920927152B
L 3811 DA 3841 4K7 3701 2702 220u 1
DIGout
1,5V 0V HF 7800 3 4 1
M 9 150p 68K 47K HF VSSA1 on DOBM COAX1/+5V PORE PORE
Monitor 1K HF FRONT D 270R 3704 GNDA
2814
ERROR PEAK sheet1 47n 2 2 2
3888
47n
4K7
4 DIG. RCK 45
PROCESSOR
2807 A Y 3816 3818 3820 3823 COAX2/EBU +5V GND
470R
0,9V 0,9V
2701
3702
10 5 6 END
22p
CORR. DET.
SUBCODE
L LASER HF L PLL 10R
E L 11 47n 2869 27p 7802-C 15K 5K6 18K 3K3
3
ISLICE
SUB 46
E 1 6 3
SHIELD/EBU_GND
3
DATA
L 7808 5803 4,8V 33R
3825
22K
4
100n
2704
3K3 7802-A 7 8 3,3V
12 TDA7073A 3 4 7802-D HFIN HFIN EBU 1822 +3.3V SCL SICL
2809 3K3 MOTOR
T- A Y 1 2 2810 3K3 9 8 2813 3824 OUTPUT INTERF. E EBUGND EBUGND 2703 1u 3880 5 E
TRACK FOCUS 3814 A Y A Y A Y 2 CONTROL STAGES SFSY 47
7875 SILD SILD
F+ 13 7802-B 11 10 3821 VERSATILE
3849 33p 33p 3822 2n2 1K
VDDD1P
BC847B 3889
VDDD2C
6,2V 16 + HFREF digital out circuitry (not for all versions) 100n
2857
2815
7802-E 6
MOTO2
MOTO1
47u
47p
2812
VSSD3
VSSD2
3819 INTERFACE SDA +5V/doorsw
DOEM
14 1
CFLG
T+ - 56K 1 SBSY 48 EBUGND B3V9 UDZ 6877 3881 @ 1K
2833
470p
2811
3850
3,9V
33p
8K2
FO
RA
3847 FE-ST-VK-N
V1
V5
V4
SL
FOCUS F- 15 FOCUS 2 3848 15K 10p HF LDON CL11|4 4806
14 + 2816 22n 150R +5V
Vref Vdd_HCU 64 63 62 61 60 59 58 57 56 55 54 53 52 51 50 49
47K 82K 2853 10n @ 0R 285610n
1 _
2832
150p
6,1V 13 3855 EYE-PATTERN LDON @

- HF ............. Vdc measured during PLAY
10V of HCU 3865 @... for provision only
SLIDE 2 +10V +3servo V EVM with normal CD or CD-R
F +
VDD
5 2836 +t
PTH8 D
VCC
1K
+5V F V Vdc measured during PLAY with CD-RW
3 6,2V 12 CD99 Schematic Part2 18081999
_ 6 47u 3853 3852 3851
Innersw
2842
1u
INNERSW. 4
3846
+
22K
7 15K 47K 56K 800mVpp D EBUGND to 1 2 3 4 5 6 7 8 9 10
470p
2835
3854
TRACK
8K2
10 Innersw M2 M1 DOBM dig. out circuitry
3845 2R2
5 -
2834
270p
+ 2830 +3servo on
DISC 6 6,0V 9 + 8 Vref
3843 1K 3842 1K
TRACK 1u sheet 2
- HF TB = 0.5m s/div
D 2831
1801 D
100R
3844
EH-S
side entry connector LOW = CD_RW (high gain) 1u
3745 10R
3750
3751
22K
22K
2829 47n
7809 3V Vref
TDA7073A
G T=1s
SLIDE 3857 3757 3856
@ @
+3.3V
+3servo G
during Focus search
16 + 0V
6,1V D D
68K 22K 68K
3858
1
2838
2837
3K9
22n
47n
- drive_recognition D +3.3V
SL FO RA for digital out: 33E
SLIDE 2
14 + Vref D
3863
6,2V 13 _
+10V
2840 3R3
5
6,5V 12 VDD
_ 6 47u 3859 47K M2
+
H connect shielding DISC 7
3860 1K D ............. Vdc measured during PLAY with normal CD or CD-R H
100n
2839
10 -
V EVM
8401 9 + V Vdc measured during PLAY with CD-RW
3861 47K
5,9V M1
DISC @... for provision only
3862 1K D
CD99 Schematic Part1 18081999
1 2 3 4 5 6 7 8 9 10 11 12 13 14 15
PCS 99 484
13-1 13-1 13-1
EXPLODED VIEW DIAGRAM - CABINET
SCREW LIST
1. T2 x 10
2. T2.5 x 10
DB
TIM
CD
ER
AU
X
TAP
E
TU
NE
R
3. T3 x 6
B SLEE
P
DS
4. T3 x 8
C
MU INC
TE .SU
RR
SID
E
; NE
WS
/T
A
– VO
LUME
+
5. T3 x10
6. T3 x12
RE SH
PE UF
AT FLE
PR
OG
RA
M
444 7. P/W C2.5 x 10

8. P/W T3 x 6
5
9. P/W T3 x 10
422 436
421
1 (3x) 504 5
443 502
4 (3x)
6 (2x)
9 (2x)
6 (4x) 6
418
434
442
416 8 (2x)
433
419 6
432
6 (2x)
431
417 3 (3x) 8 (2x)
414 6
407 438
6 413 427 8 (2x)
406 8 (4x) 9 (2x)
441
446
501 426
412
429 9 (2x)
409 411 7
402 404 6 (4x) 506
424 6 (2x)
423
408 428 439
403
7 (4x)
6 (3x)
503
401 437
PCS 104 589

13-2 13-2
MECHANICAL PARTSLIST - CABINET EXPLODED VIEW DIAGRAM - RECORDER MODULE ETF6
401 3140 117 60030 Cassette Door Assy 437 4822 462 40692 Rubber Stand
402 4822 443 10488 Door Cassette 438 3140 114 29310 Tuner Bracket
403 4822 492 42787 Spring Cassette 439 3140 114 34750 Rear Cabinet
404 3140 114 34880 Front Cabinet Cover 441 3140 113 21880 Mains Cord Relief
406 3140 117 60470 Front Window Assy 442 3140 118 50890 Packed Speaker Box Assy
407 3140 117 59350 Volume Knob Assy 443 4822 303 50082 AM Frame
408 3140 117 60000 Front Cab Assy (For -/21/21M/30/33) 444 3139 228 83200 Remote RC282424/01
408 3140 117 60010 Front Cab/RDS Assy (For -/22) 446 4822 466 93148 Spacer
409 4822 492 11344 Spring Compression 4822 303 50063 FM Antenna Wire
411 4822 529 10322 Damper Assy 3140 115 27770 Instructions Manual (For -/21/21M/30)
412 4822 492 11345 Spring Tension 3140 115 27780 Instructions Manual (For -/22)
413 4822 402 11246 Bracket Cassette
414 4822 402 10621 Push Catch
416 3140 114 36200 Front Knobs Source
417 3140 114 36210 Front Knobs Program
418 3140 117 60480 Chrome Knobs Assy

419 3140 114 34890 Front Knobs Preset
421 3140 114 29180 LCD Holder
422 4822 691 10775 Tape Deck CRH44-503
423 4822 529 10387 Damper Rubber (40 DEG)
424 4822 529 10386 Damper Rubber (30 DEG)

426 4822 691 10747 CD DA11 Drive Assy
427 4822 442 01096 CD Drive Cover
428 3140 114 34770 CD Tray
429 4822 529 10322 Damper Assy
431 4822 535 60096 Disc

432 4822 532 13153 Ring (CD Lid)
433 4822 532 12798 Ring Pressure
434 4822 492 11741 Spring CD Note: Only these parts mentioned in the list are
436 3140 117 60020 CD Door Assy normal service parts.
MECHANICAL PARTSLIST - RECORDER MODULE ETF6
1 482269110775 Tape Deck CRH44-503

4 482232012605 Flexible Foil 8P
Note: Only these parts mentioned in the list are

normal service parts.
PCS 104 590

13-3 13-3
EXPLODED VIEW DIAGRAM - TAPE DECK (CRH44-503)
MECHANICAL PARTSLIST - TAPE DECK
1 482224910521 Rec/Play Head Assy

9 482252810974 Pinch Roller Arm Assy (R)
12 482252810975 Pinch Roller Arm Assy (L)
20 482228111069 Solenoid
24 482252811304 Flywheel Assy (L)
33 482252811305 Flywheel Assy (R)

34 482235810271 Belt
36 482236110808 Motor Assy
40 482226511535 Connector Socket 8P
41 482227613704 Leaf Switch
42 482213010205 Photo Sensor

43 482205016801 680R 1% 0,4W
44 482227711749 Mode Switch
71 482249211542 Spring
72 482249211546 Spring
101 482253212931 Washer

102 482253212934 Washer
103 482253212932 Washer
104 482253212933 Washer
105 482253212935 Washer

normal service parts.
PCS 104 202

14-1 14-1
ELECTRICAL PARTSLIST - COMBI BOARD ELECTRICAL PARTSLIST - COMBI BOARD
- CAPACITORS - - CAPACITORS - - RESISTORS - - RESISTORS -
2251 532212142386 100nF 5% 63V 2516 482212233177 10nF 20% X7R 50V 3250 482205120471 470R 5% 0,1W 3348 482205120223 22K 5% 0,1W
2252 532212142386 100nF 5% 63V 2517 532212231865 1,5nF 10% X7R 63V 3251 482211711449 2K2 1% 0,1W 3349 482211710834 47K 1% 0,1W
2253 532212142386 100nF 5% 63V 2518 532212231865 1,5nF 10% X7R 63V 3252 482205120472 4K7 5% 0,1W 3350 482211710834 47K 1% 0,1W
2254 532212142386 100nF 5% 63V 2519 482212233575 220pF 5% NP0 63V 3253 482205120472 4K7 5% 0,1W 3351 482205110102 1K 2% 0,25W
2256 482212481151 22µF 50V 2520 482212233575 220pF 5% NP0 63V 3254 482211711449 2K2 1% 0,1W 3352 482205110102 1K 2% 0,25W
2257 482212440248 10µF 20% 63V 2521 532212231865 1,5nF 10% X7R 63V 3255 482205011002 1K 1% 0,4W 3353 482205120479 47R 5% 0,1W
2258 482212440769 4,7µF 20% 100V 2522 532212231865 1,5nF 10% X7R 63V 3256 482205011002 1K 1% 0,4W 3358 482205120472 4K7 5% 0,1W
2259 482212440769 4,7µF 20% 100V 2523 482212232535 680pF 10% X7R 63V 3257 482205011002 1K 1% 0,4W 3359 482211711507 6K8 1% 0,1W
2260 482212613751 47nF 10% X7R 63V 2524 482212232535 680pF 10% X7R 63V 3258 482211683884 47K 5% 0,5W 3360 482211710837 100K 1% 0.1W
2262 532212610511 1nF 5% NP0 50V 2525 482212613692 47F 1% NP0 63V 3259 482211713577 330R 1% 1,25W 3361 482205120101 100R 5% 0,1W
2264 482212440769 4,7µF 20% 100V 2526 482212613692 47F 1% NP0 63V 3260 482211713579 220K 1% 0.1W 3500 482211711454 820R 1% 0,1W
2265 482212440207 100µF 20% 25V 2527 482212233177 10nF 20% X7R 50V 3261 482211711149 82K 1% 0,1W 3501 482205120471 470R 5% 0,1W
2266 482212614585 100nF 10% X7R 50V 2528 482212233177 10nF 20% X7R 50V 3262 482205110102 1K 2% 0,25W 3502 482211652256 2K2 5% 0,5W
2267 482212440784 3300µF 20% 16V 2529 482212614585 100nF 10% X7R 50V 3263 482205120472 4K7 5% 0,1W 3503 482205120471 470R 5% 0,1W
2268 482212412012 4700µF 20% 25V 2530 482212614585 100nF 10% X7R 50V 3264 482205110102 1K 2% 0,25W 3505 482205120333 33K 5% 0,1W
2330 482212440769 4,7µF 20% 100V 2531 482212614585 100nF 10% X7R 50V 3266 482211710834 47K 1% 0,1W 3506 482205120333 33K 5% 0,1W
2331 223891019852 150nF ±80/20 25V 2532 482212614585 100nF 10% X7R 50V 3267 482211711449 2K2 1% 0,1W 3507 482205120159 15R 5% 0,1W
2332 223891019852 150nF ±80/20 25V 2533 482212613751 47nF 10% X7R 63V 3268 482211711449 2K2 1% 0,1W 3508 482205120159 15R 5% 0,1W
2337 482212142408 220nF 5% 63V 2534 482212613751 47nF 10% X7R 63V 3269 482205120223 22K 5% 0,1W 3509 482205120333 33K 5% 0,1W
2338 482212142408 220nF 5% 63V 2535 482212614585 100nF 10% X7R 50V 3271 482205024708 4R7 1% 0,6W 3510 482205120333 33K 5% 0,1W
2339 482212142408 220nF 5% 63V 2550 482212611585 22nF +80-20% Y5V 25V 3272 482205024708 4R7 1% 0,6W 3511 482211710837 100K 1% 0.1W
2340 482212142408 220nF 5% 63V 2551 482212233127 2,2nF 10% X7R 63V 3273 482205024708 4R7 1% 0,6W 3512 482211710837 100K 1% 0.1W
2341 482212440433 47µF 20% 25V 2552 482212233127 2,2nF 10% X7R 63V 3274 482205120391 390R 5% 0,1W 3513 482211683933 15K 1% 0,1W
2342 482212440433 47µF 20% 25V 2553 532212232654 22nF 10% X7R 63V 3275 482211683883 470R 5% 0,5W 3514 482211683933 15K 1% 0,1W
2343 482212233197 1nF 10% 50V 2554 482212440196 220µF 20% 16V 3276 482211711449 2K2 1% 0,1W 3515 482205120333 33K 5% 0,1W
2344 482212233197 1nF 10% 50V 2555 482212422652 2,2µF 20% 50V 3277 482211711449 2K2 1% 0,1W 3516 482205120333 33K 5% 0,1W
2345 532212232654 22nF 10% X7R 63V 2557 482212613482 470nF 80/20% 16V 3278 482211710834 47K 1% 0,1W 3517 482211710837 100K 1% 0.1W
2346 532212232654 22nF 10% X7R 63V 2558 482212233575 220pF 5% NP0 63V 3279 482205110102 1K 2% 0,25W 3518 482211710837 100K 1% 0.1W
2347 482212440433 47µF 20% 25V 2559 482212233575 220pF 5% NP0 63V 3280 482211652257 22K 5% 0,5W 3519 482211713579 220K 1% 0.1W
2348 482212440433 47µF 20% 25V 2560 482212233575 220pF 5% NP0 63V 3281 482211711449 2K2 1% 0,1W 3520 482211713579 220K 1% 0.1W
2349 482212440207 100µF 20% 25V 2561 482212481151 22µF 50V 3282 482211711449 2K2 1% 0,1W 3521 482205023303 33K 1% 0,6W
2351 482212440769 4,7µF 20% 100V 2563 482212441407 0,47µF 20% 63V 3283 482211711449 2K2 1% 0,1W 3522 482205023303 33K 1% 0,6W
2352 482212440433 47µF 20% 25V 2564 482212441407 0,47µF 20% 63V 3284 482211711449 2K2 1% 0,1W 3523 482205023303 33K 1% 0,6W
2353 532212610184 820pF 5% 50V 2565 532212232531 100pF 5% NP0 50V 3331 482205021003 10K 1% 0,6W 3524 482205023303 33K 1% 0,6W
2354 532212610184 820pF 5% 50V 2566 532212232531 100pF 5% NP0 50V 3332 482205021003 10K 1% 0,6W 3525 482211713579 220K 1% 0.1W
2500 482212441584 100µF 20% 10V 2567 482212422652 2,2µF 20% 50V 3333 482211711507 6K8 1% 0,1W 3526 482211713579 220K 1% 0.1W
2501 482212440196 220µF 20% 16V 2568 482212422652 2,2µF 20% 50V 3334 482211711507 6K8 1% 0,1W 3527 482211713579 220K 1% 0.1W
2502 482212440248 10µF 20% 63V 2569 482212421913 1µF 20% 63V 3335 482205120228 2R2 5% 0,1W 3528 482211713579 220K 1% 0.1W
2503 532212232654 22nF 10% X7R 63V 2570 482212421913 1µF 20% 63V 3336 482205120228 2R2 5% 0,1W 3529 482211652264 27K 5% 0,5W
2505 532212232531 100pF 5% NP0 50V 2571 482212613482 470nF 80/20% 16V 3337 482205120228 2R2 5% 0,1W 3530 482211652264 27K 5% 0,5W
2506 532212232531 100pF 5% NP0 50V 2573 482212614585 100nF 10% X7R 50V 3338 482205120228 2R2 5% 0,1W 3531 482211652264 27K 5% 0,5W
2507 532212232531 100pF 5% NP0 50V 3339 482205120121 120R 5% 0,1W 3532 482211652264 27K 5% 0,5W
2508 532212232531 100pF 5% NP0 50V 3340 482205120121 120R 5% 0,1W 3533 482205120333 33K 5% 0,1W
2509 532212232658 22pF 5% 50V 3341 482211652226 560R 5% 0,5W 3534 482205120333 33K 5% 0,1W
2510 532212232658 22pF 5% 50V 3342 482211652226 560R 5% 0,5W 3535 482211710837 100K 1% 0.1W
2511 482212614076 220nF +80-20% 25V 3343 482211710833 10K 1% 0,1W 3536 482211710837 100K 1% 0.1W
2512 482212614076 220nF +80-20% 25V 3344 482211710833 10K 1% 0,1W 3537 482211713579 220K 1% 0.1W
2513 482212613692 47F 1% NP0 63V 3345 482211710833 10K 1% 0,1W 3538 482211713579 220K 1% 0.1W
2514 482212613692 47F 1% NP0 63V 3346 482211710833 10K 1% 0,1W 3539 482205120223 22K 5% 0,1W
2515 482212233177 10nF 20% X7R 50V 3347 482205120223 22K 5% 0,1W 3540 482205120223 22K 5% 0,1W
PCS 104 203

14-2 14-2
ELECTRICAL PARTSLIST - COMBI BOARD ELECTRICAL PARTSLIST - COMBI BOARD
- RESISTORS - - RESISTORS - - DIODES - - MISCELLANEOUS -
3541 482205120154 150K 5% 0,1W 4334 482205120008 Jumper 6331 482213030621 Diode 1N4148 1330 824099024940 Socket Headphone
3542 482205120154 150K 5% 0,1W 4335 482205120008 Jumper 6332 482213030621 Diode 1N4148 1331 482226731176 Connector Terminal
3543 482211711149 82K 1% 0,1W 4510 482205120008 Jumper 6333 482213030621 Diode 1N4148 1550 482226520553 RCA Connector
3544 482211711149 82K 1% 0,1W 4512 482205120008 Jumper 6500 482213030621 Diode 1N4148 1551 482226710953 Connector 7P
3545 482205120822 8K2 5% 0,1W 4513 482205120008 Jumper 6550 319801053380 Diode BZX79-B3V3 1554 482226710731 Connector 6P
3546 482205120822 8K2 5% 0,1W 4560 482205120008 Jumper - IC & TRANSISTORS - 1555 482226511515 Connector 8P
3547 482205120154 150K 5% 0,1W 4561 482205120008 Jumper 482249271733 Clamp Steel (For Item 7330)
3548 482205120154 150K 5% 0,1W 4562 482205120008 Jumper 7250 932213924687 Trans BDW94CFP 482225540179 Clip Steel (For Item 7250)
3551 482205120333 33K 5% 0,1W 4563 482205120008 Jumper 7251 482213060511 Trans BC847B
3552 482205120333 33K 5% 0,1W 4564 482205120008 Jumper 7252 482213060511 Trans BC847B Note: Only these parts mentioned in the list are
7253 532213044647 Trans BC368 normal service parts.
3553 482205120822 8K2 5% 0,1W 4565 482205120008 Jumper 7254 482213063353 Trans BC369G
3554 482205120822 8K2 5% 0,1W 4566 482205120008 Jumper
3555 482211711507 6K8 1% 0,1W 4567 482205120008 Jumper 7255 482213060511 Trans BC847B
3556 482211711507 6K8 1% 0,1W 4568 482205120008 Jumper 7256 482213041246 Trans BC327-25
3557 482211710965 18K 1% 0,1W 4569 482205120008 Jumper 7257 482213041246 Trans BC327-25
7258 482213041246 Trans BC327-25
3559 482211712955 2K7 1% 0,1W 4571 482205120008 Jumper
3560 482211712955 2K7 1% 0,1W 4572 482205120008 Jumper 7260 532213060845 Trans BC807-25
3562 482205021003 10K 1% 0,6W 7330 482220916224 IC AN7125
- COILS - 7331 482213060373 Trans BC856B
3563 482205120101 100R 5% 0,1W 7332 482213060373 Trans BC856B
3565 482205120229 22R 5% 0,1W 5331 482215711837 Coil 0,36µH 10%
3566 482205120229 22R 5% 0,1W 5332 482215711837 Coil 0,36µH 10% 7333 482213060511 Trans BC847B
3568 482205110102 1K 2% 0,25W 5333 482215711837 Coil 0,36µH 10% 7500 482220910264 IC HEF4069UBD
3572 482211710833 10K 1% 0,1W 5334 482215711837 Coil 0,36µH 10% 7501 482213044568 Trans BC557B
5550 319801814770 Coil 470nH 10% 7502 482213044568 Trans BC557B
3573 482205011002 1K 1% 0,4W 7503 482213044568 Trans BC557B
3574 482211710834 47K 1% 0,1W 5551 319801814770 Coil 470nH 10%
3575 482211683933 15K 1% 0,1W 7504 482213044568 Trans BC557B
3576 482211683933 15K 1% 0,1W 7505 482213060511 Trans BC847B
3577 482205120471 470R 5% 0,1W - DIODES - 7506 482213060511 Trans BC847B
7507 482213060511 Trans BC847B
3578 482205120471 470R 5% 0,1W 6254 482213031878 Diode 1N4003G 7508 482213060511 Trans BC847B
3579 482205120154 150K 5% 0,1W 6255 482213031878 Diode 1N4003G
3580 482205120154 150K 5% 0,1W 6256 482213031878 Diode 1N4003G 7509 482213060511 Trans BC847B
3581 482211712955 2K7 1% 0,1W 6257 482213031878 Diode 1N4003G 7510 482213060511 Trans BC847B
7512 482213060511 Trans BC847B
3584 482205120472 4K7 5% 0,1W 6260 482213031878 Diode 1N4003G
3586 482211711449 2K2 1% 0,1W 6262 482213031878 Diode 1N4003G 7550 482213042804 Trans BC817-25
3587 482205120392 3K9 5% 0,1W 6263 482213031878 Diode 1N4003G 7551 482220910263 IC HEF4052BP
7552 532220910421 HEF4094BP
3588 482205120392 3K9 5% 0,1W 6264 482213031878 Diode 1N4003G 7553 932200363676 Trans TBC327-40
3589 482211683872 220R 5% 0,5W 6265 482213031878 Diode 1N4003G
4260 482205120008 Jumper 6266 482213030621 Diode 1N4148 7555 482213060511 Trans BC847B
4261 482205120008 Jumper 6267 482213030621 Diode 1N4148 7556 482213060511 Trans BC847B
4262 482205120008 Jumper 6268 319801058280 Diode BZX79-B8V2
4263 482205120008 Jumper 6269 482213030621 Diode 1N4148

4264 482205120008 Jumper 6270 482213030621 Diode 1N4148
4266 482205120008 Jumper 6272 482213061219 Diode BZX79-B10
PCS 104 204

14-3 14-3 14-3
ELECTRICAL PARTSLIST - FRONT BOARD ELECTRICAL PARTSLIST - FRONT BOARD ELECTRICAL PARTSLIST - FRONT BOARD
- CAPACITORS - - CAPACITORS - - RESISTORS - - RESISTORS - - MISCELLANEOUS -
2400 482212233177 10nF 20% X7R 50V 2450 532212234099 470pF 10% X7R 63V 3445 482211711449 2K2 1% 0,1W 3496 482205120154 150K 5% 0,1W 1400 482227613775 Push Switch
2401 482212233177 10nF 20% X7R 50V 2451 532212234099 470pF 10% X7R 63V 3446 482211713579 220K 1% 0.1W 3497 482211710833 10K 1% 0,1W 1401 482227613775 Push Switch
2402 482212423432 100µF 20% 10V 3447 482211710833 10K 1% 0,1W 3498 482211710833 10K 1% 0,1W 1402 482227613775 Push Switch
2403 482212614585 100nF 10% X7R 50V 3448 482211652243 1K5 5% 0,5W 3499 482205120223 22K 5% 0,1W 1403 482227613775 Push Switch
2404 482212423432 100µF 20% 10V - RESISTORS - 3449 482211652257 22K 5% 0,5W 4401 482205120008 Jumper 1404 482227613775 Push Switch
2405 482212233177 10nF 20% X7R 50V 3400 482211652176 10R 5% 0,5W 3450 482211710833 10K 1% 0,1W 4410 482205120008 Jumper 1405 482227613775 Push Switch
2406 482212233177 10nF 20% X7R 50V 3401 482211652182 10R 5% 0,5W 3451 482205120471 470R 5% 0,1W 4411 482205120008 Jumper 1406 482227613775 Push Switch
2407 482212614585 100nF 10% X7R 50V 3402 482211652175 100R 5% 0,5W 3452 482211710833 10K 1% 0,1W 4412 482205120008 Jumper 1407 482227613775 Push Switch
2408 482212614585 100nF 10% X7R 50V 3403 482211711507 6K8 1% 0,1W 3453 482205110102 1K 2% 0,25W 4413 482205120008 Jumper 1408 482227613775 Push Switch
2409 482212233177 10nF 20% X7R 50V 3404 482205120182 1K8 5% 0,1W 3454 482205011002 1K 1% 0,4W 4414 482205120008 Jumper 1409 482227613775 Push Switch
2410 482212233177 10nF 20% X7R 50V 3405 482205011002 1K 1% 0,4W 3455 482205110102 1K 2% 0,25W 4415 482205120008 Jumper 1410 482227613775 Push Switch
2411 482212613486 15pF 2% NP0 63V 3406 482211710837 100K 1% 0.1W 3456 482205011002 1K 1% 0,4W 4416 482205120008 Jumper 1411 482227613775 Push Switch
2412 482212613486 15pF 2% NP0 63V 3407 482205110102 1K 2% 0,25W 3457 482211710833 10K 1% 0,1W 4417 482205120008 Jumper 1412 482227613775 Push Switch
2413 482212613694 68pF 1% NP0 63V 3408 482205120474 470K 5% 0,1W 3458 482205110102 1K 2% 0,25W 4418 482205120008 Jumper 1413 482227613775 Push Switch
2414 482212233177 10nF 20% X7R 50V 3409 482211710833 10K 1% 0,1W 3459 482211683872 220R 5% 0,5W 4419 482205120008 Jumper 1414 482227613775 Push Switch
2415 482212613691 27pF 1% NP0 63V 3410 482211652175 100R 5% 0,5W 3460 482205120471 470R 5% 0,1W 1415 242212916349 Rotary Switch
2416 482212613691 27pF 1% NP0 63V 3411 482211710837 100K 1% 0.1W 3461 482211652283 4K7 5% 0,5W - COILS, CRYSTAL & FILTERS - 1416 242202514546 Connector 16P
2417 482212440433 47µF 20% 25V 3412 482211710833 10K 1% 0,1W 3462 482205120472 4K7 5% 0,1W 1418 482226511207 Connector 6P
2418 532212231647 1nF 10% X7R 63V 3413 482205110102 1K 2% 0,25W 3463 482211652283 4K7 5% 0,5W 5400 319801811580 Coil 1,5µH 5% 1420 482226710956 Connector 7P
2419 482212614585 100nF 10% X7R 50V 3414 482205120333 33K 5% 0,1W 3464 482205120472 4K7 5% 0,1W 5401 319801811580 Coil 1,5µH 5% 1425 936028030112 LCD Display
5402 482224272066 Filter CST8,00MT
2420 482212233177 10nF 20% X7R 50V 3415 482211683933 15K 1% 0,1W 3465 482211652283 4K7 5% 0,5W 5403 242254301069 Crystal 32.768kHz Note: Only these parts mentioned in the list are
2421 482212233177 10nF 20% X7R 50V 3416 482211683872 220R 5% 0,5W 3466 482205120472 4K7 5% 0,1W 5404 482224272195 Crystal 4.332MHz normal service parts.
2422 532212232531 100pF 5% NP0 50V 3417 482211683933 15K 1% 0,1W 3467 482211652256 2K2 5% 0,5W
2423 532212232531 100pF 5% NP0 50V 3418 482211711139 1K5 1% 0,1W 3468 482211711449 2K2 1% 0,1W
2424 482212614585 100nF 10% X7R 50V 3419 482211711139 1K5 1% 0,1W 3469 482211683883 470R 5% 0,5W - DIODES -
2425 532212232659 33pF 5% 50V 3420 482205021003 10K 1% 0,6W 3470 482211712955 2K7 1% 0,1W 6400 482213030621 Diode 1N4148
2426 532212232658 22pF 5% 50V 3421 482205120562 5K6 5% 0,1W 3471 482205023303 33K 1% 0,6W 6401 482213030621 Diode 1N4148
2427 532211680853 560pF 5% NP0 63V 3422 482211683883 470R 5% 0,5W 3472 482205120474 470K 5% 0,1W
2428 482212422652 2,2µF20% 50V 3423 482205011002 1K 1% 0,4W 3473 482205120472 4K7 5% 0,1W
2429 482212612787 330pF10% Y5V 50V 3424 482211711139 1K5 1% 0,1W 3474 482205011002 1K 1% 0,4W - IC & TRANSISTORS -
2430 532212231647 1nF10%X7R 63V 3425 482211711449 2K2 1% 0,1W 3475 482211713577 330R 1% 1,25W 7400 314011050760 IC TMP87CP23F
2431 532212610223 4,7nF 10% X7R 63V 3426 482205120332 3K3 5% 0,1W 3476 482211683883 470R 5% 0,5W 7402 482213060511 Trans BC847B
2432 532212232531 100pF 5% NP0 50V 3427 482205120562 5K6 5% 0,1W 3477 482205120471 470R 5% 0,1W 7403 482213060511 Trans BC847B
2433 532212232268 470pF 10% 50V 3428 482211710833 10K 1% 0,1W 3478 482211683883 470R 5% 0,5W 7404 932213714667 Remote Receiver
2434 532212232531 100pF 5% NP0 50V 3429 482205021003 10K 1% 0,6W 3479 482205120471 470R 5% 0,1W 7405 932214083682 IC M24C01-BN6
2435 532212232268 470pF 10% 50V 3430 482205120562 5K6 5% 0,1W 3480 482205011002 1K 1% 0,4W 7406 482220931981 IC SAA6579T
2436 532212232268 470pF 10% 50V 3431 482205120471 470R 5% 0,1W 3481 482205120471 470R 5% 0,1W
2437 532212232268 470pF 10% 50V 3432 482205110102 1K 2% 0,25W 3482 482205011002 1K 1% 0,4W
2438 532212232268 470pF 10% 50V 3433 482211711139 1K5 1% 0,1W 3483 482211683933 15K 1% 0,1W
2439 532212232268 470pF 10% 50V 3434 482211711449 2K2 1% 0,1W 3484 482211710833 10K 1% 0,1W
2440 482212233127 2,2nF 10% X7R 63V 3435 482205120332 3K3 5% 0,1W 3485 482211652276 3K9 5% 0,5W
2441 482212233177 10nF 20% X7R 50V 3436 482205120562 5K6 5% 0,1W 3486 482205120101 100R 5% 0,1W
2442 482212233575 220pF 5% NP0 63V 3437 482205120223 22K 5% 0,1W 3487 482211652276 3K9 5% 0,5W
2443 482212233575 220pF 5% NP0 63V 3438 482205120223 22K 5% 0,1W 3488 482205120101 100R 5% 0,1W
2444 482212233575 220pF 5% NP0 63V 3439 482205110102 1K 2% 0,25W 3489 482205011002 1K 1% 0,4W
2445 482212233575 220pF 5% NP0 63V 3440 482205110102 1K 2% 0,25W 3490 482205110102 1K 2% 0,25W
2446 482212233177 10nF 20% X7R 50V 3441 482205110102 1K 2% 0,25W 3491 482205011002 1K 1% 0,4W
2447 532212234099 470pF 10% X7R 63V 3442 482205120333 33K 5% 0,1W 3492 482205110102 1K 2% 0,25W
2448 532212234099 470pF 10% X7R 63V 3443 482205023303 33K 5% 0,1W 3493 482205011002 1K 1% 0,4W
2449 532212234099 470pF 10% X7R 63V 3444 482211652175 100R 5% 0,5W 3494 482205110102 1K 2% 0,25W
PCS 104 205

14-4 14-4 14-4
ELECTRICAL PARTSLIST - CD99 DA11 ELECTRICAL PARTSLIST - CD99 DA11 ELECTRICAL PARTSLIST - CD99 DA11
- CAPACITORS - - CAPACITORS - - RESISTORS - - RESISTORS - - RESISTORS -
2801 482212441751 47µF 20% 50V 2855 482212411912 220µF 20% 6,3V 3826 482205120273 27K 5% 0,1W 3883 482205110102 1K 2% 0,25W
4888 482205120008 Jumper
2802 482212441751 47µF 20% 50V 2857 482212412362 47µF 4V 20% 3827 482205120339 33R 5% 0,1W 3884 482205110102 1K 2% 0,25W
4889 482205120008 Jumper
2803 482212613695 82pF 1% NP0 63V 2860 532211680853 560pF 5% NP0 63V 3828 482205120479 47R 5% 0,1W 3886 482211710833 10K 1% 0,1W
2804 482212613695 82pF 1% NP0 63V 2861 532212231865 1,5nF 10% X7R 63V 3829 482205120101 100R 5% 0,1W 3887 482211710833 10K 1% 0,1W
2805 482212613695 82pF 1% NP0 63V 2862 482212610326 180pF 5%NP0 63V 3830 482205120472 4K7 5% 0,1W 3888 482205120472 4K7 5% 0,1W - COILS & FILTERS -
2806 482212613695 82pF 1% NP0 63V 2863 482212610326 180pF 5%NP0 63V 3835 482205120223 22K 5% 0,1W 3889 482205110102 1K 2% 0,25W 1810 482224273557 Filter CST8,46MTW-TF01
2807 482212613691 27pF 1% NP0 63V 2864 482212610326 180pF 5%NP0 63V 3836 482211710833 10K 1% 0,1W 3890 482211710837 100K 1% 0.1W 5803 482215711231 Coil LAN02TB1R0J
2808 532212233538 150pF 2% NP0 63V 2865 482212610326 180pF 5%NP0 63V 3837 482205120471 470R 5% 0,1W 3891 482211710837 100K 1% 0.1W
2809 482212613691 27pF 1% NP0 63V 2869 482212613751 47nF 10% X7R 63V 3838 482205120471 470R 5% 0,1W 3892 482211710837 100K 1% 0.1W - DIODES -
2810 482212613691 27pF 1% NP0 63V 2870 482212233575 220pF 5% NP0 63V 3839 482205120471 470R 5% 0,1W 3893 482211710837 100K 1% 0.1W
6877 482213011564 Diode UDZ3.9B
2811 532212232659 33pF 5% 50V 2871 482212233575 220pF 5% NP0 63V 3840 482205120471 470R 5% 0,1W 3894 482211710833 10K 1% 0,1W
2812 532212232448 10pF 5% NP0 63V 2872 482212233575 220pF 5% NP0 63V 3841 482205120472 4K7 5% 0,1W 3895 482211710833 10K 1% 0,1W
2813 482212233127 2,2nF 10% X7R 63V 2873 482212233575 220pF 5% NP0 63V - IC & TRANSISTORS -
3842 482205110102 1K 2% 0,25W 3896 482211710833 10K 1% 0,1W
2814 482212613751 47nF 10% X7R 63V 2874 482212233575 220pF 5% NP0 63V 3843 482205110102 1K 2% 0,25W 3897 482211710833 10K 1% 0,1W
2815 482212613692 47pF 1% NP0 63V 2875 482212233575 220pF 5% NP0 63V 3844 482205120101 100R 5% 0,1W 3898 482211710833 10K 1% 0,1W 7800 482220917324 IC SAA7325H
7802 532220911517 IC PC74HCU04T
2816 532212232654 22nF 10% X7R 63V 3845 482205120228 2R2 5% 0,1W 3899 482211710833 10K 1% 0,1W 7803 532213060123 Trans BC807-40
2817 482212440769 4,7µF 20% 100V 3846 482205120223 22K 5% 0,1W 3900 482205120223 22K 5% 0,1W 7804 532220982941 IC LM358D
2818 482212613751 47nF 10% X7R 63V 3847 482211711149 82K 1% 0,1W 4801 482205120008 Jumper 7807 532213042755 Trans BC847C
2821 482212614585 100nF 10% X7R 50V 3848 482211710834 47K 1% 0,1W 4802 482205120008 Jumper
2822 482212613344 1,5nF 5% 63V - RESISTORS - 3849 482211711148 56K 1% 0,1W 4807 482205120008 Jumper
7808 482220932852 IC TDA7073A/N2
7809 482220932852 IC TDA7073A/N2
2823 482212442383 220µF 20% 4V 3728 482205120479 47R 5% 0,1W 3850 482205120822 8K2 5% 0,1W 4808 482205120008 Jumper
2824 482212613751 47nF 10% X7R 63V 3745 482205120109 10R 5% 0,1W 3851 482211711148 56K 1% 0,1W 4809 482205120008 Jumper 7810 482220933165 IC TDA1308T/N1
2825 482212613344 1,5nF 5% 63V 3757 482205120223 22K 5% 0,1W 3852 482211710834 47K 1% 0,1W 4810 482205120008 Jumper 7875 482213060511 Trans BC847B
2826 482212613751 47nF 10% X7R 63V 3788 482205120472 4K7 5% 0,1W 3853 482211683933 15K 1% 0,1W 4812 482205120008 Jumper
2827 532212231647 1nF 10% X7R 63V 3800 482205120478 4R70 5% 0,1W 3854 482205120822 8K2 5% 0,1W 4813 482205120008 Jumper - MISCELLANEOUS -
2828 482212613692 47pF 1% NP0 63V 3801 482205120154 150K 5% 0,1W 3855 482211640227 4R6 25% 12V 4814 482205120008 Jumper 1800 482226510925 Connector 15P
2829 482212613751 47nF 10% X7R 63V 3802 482205110102 1K 2% 0,25W 3856 482205120683 68K 5% 0,1W 4815 482205120008 Jumper 1823 482226511207 Connector 6P
2830 482212614043 1µF +80-20% Y5V 16V 3803 482205120273 27K 5% 0,1W 3857 482205120683 68K 5% 0,1W 4823 482205120008 Jumper 1824 482226511207 Connector 6P
2831 482212614043 1µF +80-20% Y5V 16V 3804 482205120472 4K7 5% 0,1W 3858 482205120392 3K9 5% 0,1W 4824 482205120008 Jumper
8000 482232012178 Flexible Foil 15P
2832 532212233538 150pF 2% NP0 63V 3805 482205120273 27K 5% 0,1W 3859 482211710834 47K 1% 0,1W 4828 482205120008 Jumper
2833 532212232268 470pF 10% 50V 3806 482211710361 680R 1% 0,1W 3860 482205110102 1K 2% 0,25W 4831 482205120008 Jumper Note :Only these parts mentioned in the list are
2834 482212233216 270pF 5% NP0 50V 3807 482211711139 1K5 1% 0,1W 3861 482211710834 47K 1% 0,1W 4832 482205120008 Jumper normal service parts.
2835 532212232268 470pF 10% 50V 3808 482205120339 33R 5% 0,1W 3862 482205110102 1K 2% 0,25W 4838 482205120008 Jumper
2836 482212441751 47µF 20% 50V 3809 482205120339 33R 5% 0,1W 3863 482205210338 3R3 5% 0,33W 4845 482205120008 Jumper
2837 482212613751 47nF 10% X7R 63V 3810 482205210478 4R7 5% 0,33W 3864 482211710833 10K 1% 0,1W 4847 482205120008 Jumper
2838 532212232654 22nF 10% X7R 63V 3811 482205110102 1K 2% 0,25W 3865 482205110102 1K 2% 0,25W 4848 482205120008 Jumper
2839 482212614585 100nF 10% X7R 50V 3812 482205120474 470K 5% 0,1W 3867 482205120223 22K 5% 0,1W 4850 482205120008 Jumper
2840 482212441751 47µF 20% 50V 3813 482205120683 68K 5% 0,1W 3868 482211710833 10K 1% 0,1W 4853 482205120008 Jumper
2841 482212613751 47nF 10% X7R 63V 3814 482205120332 3K3 5% 0,1W 3869 482211710833 10K 1% 0,1W 4856 482205120008 Jumper
2842 482212421913 1µF 20% 63V 3815 482205120472 4K7 5% 0,1W 3871 482205120471 470R 5% 0,1W 4857 482205120008 Jumper
2845 482212233575 220pF 5% NP0 63V 3818 482205120562 5K6 5% 0,1W 3874 482205120223 22K 5% 0,1W 4865 482205120008 Jumper
2846 482212440248 10µF 20% 63V 3819 482211683933 15K 1% 0,1W 3875 482211710833 10K 1% 0,1W 4866 482205120008 Jumper
2849 482212233575 220pF 5% NP0 63V 3821 482205120332 3K3 5% 0,1W 3878 482205120471 470R 5% 0,1W 4877 482205120008 Jumper
2850 482212233575 220pF 5% NP0 63V 3822 482205120332 3K3 5% 0,1W 3879 482211710834 47K 1% 0,1W 4881 482205120008 Jumper
2851 482212440248 10µF 20% 63V 3823 482205120332 3K3 5% 0,1W 3880 482205120339 33R 5% 0,1W 4884 482205120008 Jumper
2853 482212233177 10nF 20% X7R 50V 3824 482205110102 1K 2% 0,25W 3881 482211710353 150R 1% 0,1W 4885 482205120008 Jumper
2854 482212411912 220µF 20% 6,3V 3825 482205120223 22K 5% 0,1W 3882 482205120101 100R 5% 0,1W 4886 482205120008 Jumper
PCS 99 490
14-5 14-5
ELECTRICAL PARTSLISL - TUNER BOARD ECO6 (Cenelec) ELECTRICAL PARTSLISL - TUNER BOARD ECO6 (Cenelec)
- CAPACITORS - - RESISTORS - - COILS & FILTERS -
2106 202080000204 Var Cap 4,2pF-20pF 100V 3128 482211711449 2K2 1% 0,1W 5122 242254944108 Coil 796kHz
2107 482212151319 1µF 10% 63V 3132 482205120479 47R 5% 0,1W 5123 242254944108 Coil 796kHz
2108 532212232531 100pF 5% NP0 50V 3134 482205120223 22K 5% 0,1W
2109 532212232448 10pF 5% NP0 63V 3137 482205120223 22K 5% 0,1W - DIODES -
2120 532212232658 22pF 5% 50V 3141 482211711148 56K 1% 0,1W
6105 482213083075 Diode HN1V02H-B
2122 482212233891 3,3nF 10% X7R 63V 3142 482210012159 100K 30% 6106 482213083757 Diode BAS216
2123 202055293494 Ceramic 390pF 50V 3143 482205120223 22K 5% 0,1W 6107 934038690115 Diode BZX284-C11
2125 202055296199 Ceramic 560pF 50V 3144 482205110102 1K 2% 0,25W 6120 482213083757 Diode BAS216
2127 482212614076 220nF 25V P8020 3145 482211711449 2K2 1% 0,1W
2128 482212440248 10µF 20% 63V 3146 482205120229 22R 5% 0,1W - IC & TRANSISTORS -
2129 482212441584 100µF 20% 10V 3150 482211710833 10K 1% 0,1W 7101 482220990315 IC TEA5762H/V1
2130 532212232654 22nF 10% X7R 63V 3151 482205120683 68K 5% 0,1W 7103 532213042756 Trans BC857C
2131 482212613482 470nF 80/20% 16V 3152 482205120471 470R 5% 0,1W 7104 932200364676 Trans TBC337-40
2132 482212613482 470nF 80/20% 16V 3153 482205120471 470R 5% 0,1W 7105 932200364676 Trans TBC337-40
2133 482212421913 1µF 20% 63V 3154 482211713577 330R 1% 1,25W 7109 482213060373 Trans BC856B
2134 482212613188 15nF 5% X7R 63V 3155 482211710353 150R 1% 0,1W 7110 482213060373 Trans BC856B
2135 482212613188 15nF 5% X7R 63V 3158 482205120471 470R 5% 0,1W 7112 482213044503 Trans BC547C
2136 482212614076 220nF 25V P8020 3159 482205120471 470R 5% 0,1W 7122 532213042755 Trans BC847C
2137 482212614076 220nF 25V P8020 3160 482205120471 470R 5% 0,1W 7124 532213042755 Trans BC847C
2138 482212422652 2,2µF 20% 50V 3161 482205120223 22K 5% 0,1W
- MISCELLANEOUS -
2139 482212614236 15pF 5% 50V 3167 482205120121 120R 5% 0,1W
2140 482212613695 82pF 1% NP0 63V 3168 482205120121 120R 5% 0,1W 1102 482226710283 Connector YKD31-0432
2141 482212613838 100nF Y5V 50V P80M20 3169 482205120154 150K 5% 0,1W 1103 482226531184 Connector S2B-XH-A-BK
2143 482212614076 220nF 25V P8020 3171 482211710834 47K 1% 0,1W 1110 242254290071 FM Frontend FE450-G01
2144 482212421913 1µF 20% 63V 3172 482205120562 5K6 5% 0,1W 1120 482226511515 Connector 8P
2145 482212233575 220pF 5% NP0 63V 3176 482205120333 33K 5% 0,1W Note: Only these parts mentioned in the list are
2146 482212233575 220pF 5% NP0 63V 3180 482211710833 10K 1% 0,1W normal service parts.
2147 482212233575 220pF 5% NP0 63V 3190 482205120121 120R 5% 0,1W
2148 482212233127 2,2nF 10% X7R 63V 3191 482205120121 120R 5% 0,1W
2149 532212232659 33pF 5% 50V 3192 482211713577 330R 1% 1,25W
2150 482212613838 100nF Y5V 50V P80M20 3193 482211713577 330R 1% 1,25W
2159 532212232659 33pF 5% 50V 3194 482211711449 2K2 1% 0,1W
2162 482212481151 22µF 50V 3195 482205120101 100R 5% 0,1W
2163 482212613838 100nF Y5V 50V P80M20 4105 482205120008 Jumper
2164 482212613482 470nF 80/20% 16V 4106 482205120008 Jumper
2165 482212613838 100nF Y5V 50V P80M20 4107 482205120008 Jumper

2166 532212231647 1nF 10% X7R 63V
2167 482212233926 12pF 50V - COILS, CRYSTAL & FILTERS -
2169 482212233127 2,2nF 10% X7R 63V
5102 482215771634 MW Aerial
5103 242254944107 Coil 252kHz
5109 482215771639 Filter SFE10,7MJA10H-A-TF21
5110 482224270665 Filter SFE10,7MS3-A
- RESISTORS - 5111 242254944023 Coil 450kHz
3105 482211711503 220R 1% 0.1W 5112 482215770302 Coil F7MCS-12216N

3108 482211711449 2K2 1% 0,1W 5114 482215770302 Coil F7MCS-12216N
3109 482205120472 4K7 5% 0,1W 5115 482215771636 Birdie Coil
3123 482205120472 4K7 5% 0,1W 5119 482215711443 Coil 2,4µH
3125 482211710833 10K 1% 0,1W 5121 482224210261 Crystal T6252F00 75kHz
PCS 104 591

14-6 14-6
ELECTRICAL PARTSLIST - TUNER BOARD ECO6 (Non Cenelec) ELECTRICAL PARTSLIST - TUNER BOARD ECO6 (Non Cenelec)
- CAPACTORS - - RESISTORS - - IC & TRANSISTORS -
2101 482212613692 47pF 1% NP0 63V 3132 482205120479 47R 5% 0,1W 7101 935174080557 IC TEA5757H/V1
2103 532212231647 1nF 10% X7R 63V 3134 482205120223 22K 5% 0,1W 7102 482213042131 Trans BF550
2104 532212232531 100pF 5% NP0 50V 3141 482211711148 56K 1% 0,1W 7111 532213042755 Trans BC847C
2106 202080000191 Var Cap 3pF-11pF 100V 3142 482210012159 100K 30% 7112 482213044503 Trans BC547C
2107 482212151319 1µF 10% 63V 3145 482211711449 2K2 1% 0,1W
- MISCELLANEOUS -
2120 482212613689 18pF 1% NP0 63V 3146 482205120229 22R 5% 0,1W
2124 532212232654 22nF 10% X7R 63V 3152 482205120471 470R 5% 0,1W 1102 482226710283 Connector YKD31-0432
2125 202055296199 Ceramic 390pF 50V 3153 482205120471 470R 5% 0,1W 1103 482226531184 Connector S2B-XH-A-BK
2126 532212231863 Ceramic 330pF 63V 3154 482211713577 330R 1% 1,25W 1120 482226511515 Connector 8P
2127 482212614076 220nF 25V P8020 3155 482211711503 220R 1% 0.1W
2128 482212440248 10µF 20% 63V 3156 482211710837 100K 1% 0.1W normal service parts.
2129 482212441584 100µF 20% 10V 3158 482205120471 470R 5% 0,1W
2130 532212232654 22nF 10% X7R 63V 3159 482205120471 470R 5% 0,1W
2131 482212613482 470nF 80/20% 16V 3160 482205120471 470R 5% 0,1W
2132 482212613482 470nF 80/20% 16V 3161 482205120223 22K 5% 0,1W
2133 482212421913 1µF 20% 63V 3167 482205120121 120R 5% 0,1W

2134 482212613188 15nF 5% X7R 63V 3168 482205120121 120R 5% 0,1W
2135 482212613188 15nF 5% X7R 63V 3169 482205120154 150K 5% 0,1W
2136 482212614076 220nF 25V P8020 3170 482211710837 100K 1% 0.1W
2137 482212614076 220nF 25V P8020 3172 482205120562 5K6 5% 0,1W
2138 482212422652 2,2µF 20% 50V 3181 482205110102 1K 2% 0,25W

2139 482212614236 15pF 5% 50V 4103 482205120008 Jumper
2140 482212613695 82pF 1% NP0 63V 4106 482205120008 Jumper
2141 482212613838 100nF Y5V 50V P80M20 4107 482205120008 Jumper
2143 482212614076 220nF 25V P8020 4108 482205120008 Jumper
2144 482212421913 1µF 20% 63V - COILS & FILTERS -

2145 482212233575 220pF 5% NP0 63V
2146 482212233575 220pF 5% NP0 63V 5102 482215771634 MW Aerial
2147 482212233575 220pF 5% NP0 63V 5109 482224270665 Filter SFE10,7MS3-A
2148 482212233127 2,2nF 10% X7R 63V 5110 482224270665 Filter SFE10,7MS3-A
5111 242254944023 Coil 450kHz
2150 482212613838 100nF Y5V 50V P80M20 5112 482215770302 Coil F7MCS-12216N
2152 482212612105 Ceramic 33nF 50V
2153 482212613486 15pF 2% NP0 63V 5114 482215770302 Coil F7MCS-12216N
2155 202080000191 Var Cap 3pF-11pF 100V 5119 482215711443 Coil 2,4µH
2159 532212232659 33pF 5% 50V 5121 482224210261 Crystal T6252F00 75kHz
5123 242254944108 Coil 796kHz
2164 482212613482 470nF 80/20% 16V 5130 482215711843 Coil MD7B-01F
2165 482212613838 100nF Y5V 50V P80M20
2166 532212231647 1nF 10% X7R 63V 5131 482215711843 Coil MD7B-01F
2167 482212233926 12pF 50V
- RESISTORS - - DIODES -
3101 482205120333 33K 5% 0,1W 6103 532213034337 Diode BAV99

3102 482211710837 100K 1% 0.1W 6105 482213083075 Diode HN1V02H-B
3103 482205120822 8K20 5% 0,1W 6106 482213083757 Diode BAS216
3104 482211713577 330R 1% 1,25W 6107 934038690115 Diode BZX284-C11
3105 482211711503 220R 1% 0.1W 6130 482213082833 Diode 1SV228
6131 482213082833 Diode 1SV228
PCS 104 592

14-7 14-7
ELECTRICAL PARTSLIST - RECORDER BOARD ETF6 ELECTRICAL PARTSLIST - RECORDER BOARD ETF6
- CAPACITORS - - CAPACITORS - - RESISTORS - - RESISTORS -
2621 532212231647 1nF 10% X7R 63V 2781 482212233177 10nF 20% X7R 50V 3718 482211711449 2K2 1% 0,1W 3774 482211710833 10K 1% 0,1W
2622 532212234099 470pF 10% X7R 63V 2782 532212610223 4,7nF 10% X7R 63V 3719 482205120472 4K7 5% 0,1W 3775 482205120478 4R7 5% 0,1W
2623 532212234099 470pF 10% X7R 63V 2784 482212151305 15nF 10% 50V 3720 482205120472 4K7 5% 0,1W 3776 482211711507 6K8 1% 0,1W
2624 482212614585 100nF 10% X7R 50V 2785 482212421913 1µF 20% 63V 3721 482205120562 5K6 5% 0,1W 3777 482211710353 150R 1% 0,1W
2625 482212614585 100nF 10% X7R 50V 2786 532212232531 100pF 5% NP0 50V 3722 482205120562 5K6 5% 0,1W 3778 482205210688 6R80 5% 0,33W
2701 532212233538 150pF 2% NP0 63V 2787 482212612105 33nF 5% 50V 3723 482211711383 12K 1% 0,1W 3779 482205120334 330K 5% 0,1W
2702 532212233538 150pF 2% NP0 63V 3724 482211711383 12K 1% 0,1W 3780 482205120105 1M 5% 0,1W
2703 532212232531 100pF 5% NP0 50V 3725 482205120109 10R 5% 0,1W 3781 482205120475 4M7 5% 0,1W
2704 532212232531 100pF 5% NP0 50V 3726 482205120109 10R 5% 0,1W 3784 482205110102 1K 2% 0,25W
2707 532212234099 470pF 10% X7R 63V - RESISTORS - 3727 482205120562 5K6 5% 0,1W 3786 482205120223 22K 5% 0,1W
2708 532212234099 470pF 10% X7R 63V 3601 482211711449 2K2 1% 0,1W 3728 482205120562 5K6 5% 0,1W 3787 482205120105 1M 5% 0,1W
2709 532212231863 330pF 5% 63V 3602 482205120273 27K 5% 0,1W 3729 482211712955 2K7 1% 0,1W 3788 482205120105 1M 5% 0,1W
2710 532212231863 330pF 5% 63V 3603 482211711449 2K2 1% 0,1W 3730 482211712955 2K7 1% 0,1W 3789 482211710834 47K 1% 0,1W
2711 532212232531 100pF 5% NP0 50V 3604 482211711148 56K 1% 0,1W 3731 482211711507 6K8 1% 0,1W 4701 482205120008 Jumper
2712 532212232531 100pF 5% NP0 50V 3605 482211711449 2K2 1% 0,1W 3732 482211711507 6K8 1% 0,1W 4702 482205120008 Jumper
2713 482212440248 10µF 20% 63V 3606 482205120124 120K 5% 0,1W 3733 482205110102 1K 2% 0,25W 4703 482205120008 Jumper
2714 482212440248 10µF 20% 63V 3607 482211652256 2K2 5% 0,5W 3734 482205110102 1K 2% 0,25W 4704 482205120008 Jumper
2715 482212440196 220µF 20% 16V 3608 482205120273 27K 5% 0,1W 3735 482205120223 22K 5% 0,1W 4705 482205120008 Jumper
2716 482212440196 220µF 20% 16V 3609 482211652256 2K2 5% 0,5W 3736 482205120223 22K 5% 0,1W 4706 482205120008 Jumper
2717 482212233177 10nF 20% X7R 50V 3610 482205120124 120K 5% 0,1W 3741 482211711449 2K2 1% 0,1W 4707 482205120008 Jumper
2718 482212233177 10nF 20% X7R 50V 3611 482211652256 2K2 5% 0,5W 3742 482211711449 2K2 1% 0,1W 4708 482205120008 Jumper
2719 482212612105 33nF 5% 50V 3612 482211711148 56K 1% 0,1W 3743 482205120122 1K2 5% 0,1W 4709 482205120008 Jumper
2720 482212612105 33nF 5% 50V 3613 482205120273 27K 5% 0,1W 3744 482205120122 1K2 5% 0,1W 4710 482205120008 Jumper
2721 532212231866 6,8nF 10%X7R 63V 3614 482205120273 27K 5% 0,1W 3745 482205120332 3K3 5% 0,1W 4711 482205120008 Jumper
2722 532212231866 6,8nF 10%X7R 63V 3624 482211710837 100K 1% 0.1W 3746 482205120332 3K3 5% 0,1W 4712 482205120008 Jumper
2723 482212613188 15nF 5% X7R 63V 3626 482205110102 1K 2% 0,25W 3748 482211711449 2K2 1% 0,1W 4713 482205120008 Jumper
2724 482212613188 15nF 5% X7R 63V 3628 482211710837 100K 1% 0.1W 3749 482211710834 47K 1% 0,1W 4714 482205120008 Jumper
2725 532212610223 4,7nF 10% X7R 63V 3630 482205120471 470R 5% 0,1W 3751 482211710833 10K 1% 0,1W 4715 482205120008 Jumper
2726 532212610223 4,7nF 10% X7R 63V 3674 482211652283 4K7 5% 0,5W 3752 482211710837 100K 1% 0.1W 4716 482205120008 Jumper
2727 532212231647 1nF 10% X7R 63V 3676 482211710834 47K 1% 0,1W 3753 482211710837 100K 1% 0.1W 4717 482205120008 Jumper
2728 532212231647 1nF 10% X7R 63V 3678 482211710834 47K 1% 0,1W 3754 482205120105 1M 5% 0,1W 4718 482205120008 Jumper
2729 482212233735 27nF 10% X7R 63V 3680 482211710834 47K 1% 0,1W 3755 482205120105 1M 5% 0,1W 4719 482205120008 Jumper
2730 482212233735 27nF 10% X7R 63V 3685 482211652234 100K 5% 0,5W 3756 482211713579 220K 1% 0.1W 4720 482205120008 Jumper
2733 532212234099 470pF 10% X7R 63V 3686 482211710837 100K 1% 0.1W 3757 482211713579 220K 1% 0.1W 4721 482205120008 Jumper
2734 532212234099 470pF 10% X7R 63V 3689 482205120472 4K7 5% 0,1W 3758 482211710833 10K 1% 0,1W 4722 482205120008 Jumper
2735 482212614585 100nF 10% X7R 50V 3701 482211711503 220R 1% 0.1W 3759 482211710833 10K 1% 0,1W 4723 482205120008 Jumper
2737 482212614585 100nF 10% X7R 50V 3702 482211711503 220R 1% 0.1W 3760 482205120121 120R 5% 0,1W 4724 482205120008 Jumper
2738 482212614585 100nF 10% X7R 50V 3705 482211711503 220R 1% 0.1W 3761 482205021003 10K 1% 0,6W 4725 482205120008 Jumper
2741 482212611585 22nF +80-20% Y5V 25V 3706 482211711503 220R 1% 0.1W 3762 482211711454 820R 1% 0,1W 4726 482205120008 Jumper
2742 532212232654 22nF 10% X7R 63V 3707 482205120101 100R 5% 0,1W 3763 482205120154 150K 5% 0,1W 4727 482205120008 Jumper
2743 532212232654 22nF 10% X7R 63V 3708 482205120101 100R 5% 0,1W 3764 482211683872 220R 5% 0,5W 4728 482205120008 Jumper
2744 482212614585 100nF 10% X7R 50V 3709 482205120688 6R8 5% 0,1W 3765 482205120393 39K 5% 0,1W 4729 482205120008 Jumper
2760 482212614585 100nF 10% X7R 50V 3710 482205120688 6R8 5% 0,1W 3766 482205120475 4M7 5% 0,1W 4730 482205120008 Jumper
2761 482212480144 220µF 20% 25V 3711 482205120154 150K 5% 0,1W 3767 482205120475 4M7 5% 0,1W 4731 482205120008 Jumper
2762 482212440769 4,7µF 20% 100V 3712 482205120154 150K 5% 0,1W 3768 482211710833 10K 1% 0,1W 4732 482205120008 Jumper
2763 482212440433 47µF 20% 25V 3713 482205120109 10R 5% 0,1W 3769 482211711383 12K 1% 0,1W 4733 482205120008 Jumper
2765 482212440433 47µF 20% 25V 3714 482205120109 10R 5% 0,1W 3770 482211711139 1K5 1% 0,1W 4734 482205120008 Jumper
2769 532212234099 470pF 10% X7R 63V 3715 482205120182 1K8 5% 0,1W 3771 482205120122 1K2 5% 0,1W 4735 482205120008 Jumper
2770 532212234099 470pF 10% X7R 63V 3716 482205120182 1K8 5% 0,1W 3772 482205120472 4K7 5% 0,1W 4736 482205120008 Jumper
2780 482212481151 22µF 50V 3717 482211711449 2K2 1% 0,1W 3773 482210012227 4K7 30% 1W 4737 482205120008 Jumper
PCS 104 593

14-8 14-8
ELECTRICAL PARTSLIST - RECORDER BOARD ETF6 ELECTRICAL PARTSLIST - LED BOARD ELECTRICAL PARTSLIST - POWER BOARD
- RESISTORS - - IC & TRANSISTORS - - RESISTORS - - MISCELLANEOUS -
4738 482205120008 Jumper 7792 482213060511 Trans BC847B 3901 482205120121 120R 5% 0,1W 1600 482227210269 Voltage Selector (For -/21/21M)
4739 482205120008 Jumper 3902 482205120121 120R 5% 0,1W 1601 482207153152 Fuse 3.15A
4740 482205120008 Jumper - MISCELLANEOUS - 3903 482205120121 120R 5% 0,1W 1602 482207152002 Fuse 2A
4741 482205120008 Jumper 3904 482205120121 120R 5% 0,1W 3600 482205321106 10M 5% 0,5W (For -/37)
4742 482205120008 Jumper 1003 482232012605 Flexible Foil 8P 5600 482215711832 Filter 400µH 3A
1701 482226710953 Connector 7P - DIODES -
4785 482205120008 Jumper 1706 482226710953 Connector 7P 5601 314011832440 Transf 120/230V (For -/21/21M)
4790 482205120008 Jumper 1760 482226511515 Connector 8P 6901 932203320682 LED TLHG4405 5601 314011832430 Transf 230V (For -/22/25/30/33)
4794 482205120008 Jumper 6902 932203320682 LED TLHG4405
Note: Only these parts mentioned in the list are 6903 932203320682 LED TLHG4405 Note: only these parts mentioned in the list are
- COILS - normal service parts. 6904 932203320682 LED TLHG4405 normal service parts.
6905 932203320682 LED TLHG4405
5701 482215711477 Coil 2,2µH
5703 482215620946 Osc Coil 100kHz 6906 932203320682 LED TLHG4405
6907 932203320682 LED TLHG4405
- DIODES - 6908 932203320682 LED TLHG4405
6909 932203320682 LED TLHG4405
6612 482213031878 Diode 1N4003G 6910 932203320682 LED TLHG4405
6770 482213030621 Diode 1N4148
6771 482213030621 Diode 1N4148 6911 932203320682 LED TLHG4405
6772 482213030621 Diode 1N4148 6912 932203320682 LED TLHG4405
6773 482213030621 Diode 1N4148
Note: only these parts mentioned in the list are
6774 482213030621 Diode 1N4148 normal service parts.
6775 482213030621 Diode 1N4148
6776 482213030621 Diode 1N4148
6777 482213034382 Diode BZX79-B8V2
6778 482213030621 Diode 1N4148 ELECTRICAL PARTSLIST - MISCELLANEOUS
6782 482213030621 Diode 1N4148 - MISCELLANEOUS -

6785 482213030621 Diode 1N4148
6786 482213030621 Diode 1N4148 1025 482227613963 CD Door Switch
8000 314011021250 FFC Foil 16P
- IC & TRANSISTORS - 8001 314011021220 FFC Foil 6P
8005 314011021210 FFC Foil 6P
7610 532220911306 IC HEF4094BT 8007 314011021240 FFC Foil 8P
7612 532213060845 Trans BC807-25
7614 532213060845 Trans BC807-25 8008 482232110781 Mains Cord (For -/21/21M/22/25)
7618 482213060511 Trans BC847B 8008 482232110971 Mains Cord (For -/30)
7620 482213060511 Trans BC847B 8008 482232110814 Mains Cord (For -/33)
8009 314011021230 FFC Foil 7P
7622 482213060511 Trans BC847B 8010 314011021200 FFC Foil 7P
7623 482213060511 Trans BC847B
7624 482213060511 Trans BC847B Note: only these parts mentioned in the list are
7710 482220932919 IC HEF4952BT normal service parts.
7720 482220932918 IC AN7318S
7730 482220932919 IC HEF4952BT

7740 482220932919 IC HEF4952BT
7780 482213060511 Trans BC847B
7781 482213042804 Trans BC817-25
7782 482213044568 Trans BC557B
7783 482213060511 Trans BC847B

7784 482213060373 Trans BC856B
7786 482213063494 Trans J111
7787 482213060511 Trans BC847B
7791 482213060511 Trans BC847B
PCS 104 594

Philips Mc20 SM

Uploaded by

Document Informationclick to expand document informationService manual

Document Informationclick to expand document information

Copyright:

Available Formats

Philips Mc20 SM

Uploaded by

Document Information

Original Title

Copyright

Available Formats

Share this document

Share or Embed Document

Sharing Options

Did you find this document useful?

Is this content inappropriate?

Copyright:

Available Formats

Philips Mc20 SM

Uploaded by

Copyright:

Available Formats

Micro System MC-20

Block Diagram ............................................................. 5 - 1 RECORDER BOARD

Safety regulations require that the set be restored to its original

PCS 104 581

© WARNING ESD ñ WAARSCHUWING

PCS 104 437

GENERAL TUNER - AM SECTION

Output power mains : 2 x 8 W

Audio signal disc SBC 429........ ..............................................................4822 397 30184

Universal test cassette Fe SBC 420 ........................................................4822 397 30071

AVAILABLE ESD PROTECTION EQUIPMENT

PCS 104 582

S/N and distortion meter

S/N and distortion meter S/N and distortion meter

LEVEL METER LEVEL METER

2 SELECT SOURCE CD programme. 5 *

– switches on the system. (É ) .................... starts CD/Tape playback. ^ Å

2 SOURCE 5 7 CLOCK/ RDS ................................. fast rewind/wind tape or during

6 for Tuner ............. displays RDS information. passages.

PCS 104 583

PCS 104 584

PREV NEXT indication)/ ROCK ( ) / JAZZ ( )/

¶ Use a finalised CD-R(W). POP ( ) .

Recordables and CD-Rewritables.

PCS 104 585

PCS 104 586

‹ NEWS ON, TA ON or OFF is Å

PCS 104 587

PCS 104 588

VOLUME RECORDER) control once or more.

than 2 seconds. selected a time. Once SLEEP is activated, SLEEP

displayed. 4 Turn VOLUME to set the hours: clockwise for

A. To remove Cabinet Rear

PCS 104 191

To enter Service * Door switch is ignored Æ CD door can be opened.

DISPLAY TEST CD SERVO TEST

Display shows all Y Y Y

DBB CD TIMER TUNER

fig. 1 Display shows

STEREO CD ERROR CODES

Y E1000 Focus error

jumps in steps of jumps in steps of E1005 Jump error

E1006 Subcode error W

PCS 104 192

SERVO PROCESSOR SAA7325H SERVO PROCESSOR SAA7325H

+12V_S (MC10) +5V6_S A0/A1

+MOT (MC10) +5V +5V6S (MC10)

SHIFT ON / OFF -8V2

MPX RDS +5V6 +MOT

PCS 104 564

PCS 104 193

To / From COMBI BOARD

40 0V 100R 3488 TA_ADC1

+uP VDD1 P16 CD_SICL 3478 470R T423

7406 3405 2407 T424

BC847B 10n 5403 1

2424 4.5V T444 TAPE_REC