X6905 1969 GMC Wiring Diagrams After August 12 1968

X-6905
INTRODUCTION
This booklet contains Wiring D iagrams for GM C Trucks built after August 12,
1968.
To determine which diagrams are applicable :0 a specific truck series, refer to
the W iring Diagram Index which follows. F o r convenience, the index is divided
into three groups in the following order: Gasoline Engine Models, T oro-Flow
II Diesel Models, and Series 53, 71 and Cummins Diesel Models.
N O T E : Six diagrams (T -5296 through T -5301) do not appear in the index. These
are schem atic diagrams of Body Builders Connections.
TRUCKS
GMC TRUCK & COACH DIVISION

GENERAL MOTORS CORPORATION
Pontiac, Michigan
7M
1 2-68
Printed in U.S.A.
WIRING DIAGRAM INDEX

Diagrams are Bound in Numerical (MD No. and T No.) Sequence
GASOLINE ENGINE MODELS
TRUCK SERIES
CE-1500-2500
CM-1500-2500
CS-1500-2500
GE/GS-1500-2500
KE-1500-2500
KM-1500-2500
PS-1500
PE/PS-2500-3500
CE-3500
CM-3500
CS-3500
LA/LV-4000
CE-4500V
EM/ES-4500V
EM-4500M
PS-4500
CE-5500V
EM-5500 A /V
EM-5500M
ES-5500V
SM-5500 M /Y
SS-5500M
CE-6500 A /V
EM-6500 A /V
ME-6500 A /V
SM-6500 M /Y
HM/JM-7500V
HM/JM-7500A
TM-7500
RM-7500
HM /JM-8500
TM /W M -8500
HM-8721B
HE/JE-9500
TE/WE-9500
(1)
<3)
CAB,
ENGINE,
& CHASSIS
MISC.
R.P.O.
EQUIPMENT
ENGINE
ONLY
CAB
ONLY
CHASSIS
ONLY
T -6331
T -6330
T -6332
T-6344
T-6344
T-6344
T -6341
T-6341
T -6341
T -6331
T-6330
T -6333
T -6334
T -6331
T-6330
T -6332
T-6344
T-6344
T-6341
T-6341
T-6352
T -6352
T-6352
T -6353
T-6352
T-6352
T-6344
T-6344
T-6344
T-6342
T-6342
T-6342
T-6352
T-6352
T-6352
T -6335
T -6345
T-6341(1)
T-6352
T -6336
T-6335
T-6345
T-6341(1)
T-6352
T -6340
T -6349
T-6341(1)
T-6352
T -6340
T-6349
T-6341
T-6352
T -6351
MD-3281(2)
MD-3800
MD-2840
MD-3800
MD-2840
MD-3800
MD-2840
MD-2840
MD-3800
MD-2840
MD-3776
MD-3747
MD-3281(2)
MD-99264(3)
MD-3777
MD-3283
MD-3244
MD-3748
MD-3280
T-6342-P LATFO R M
(2) MD-3283-H.D. WIRING
MD-3357 ENGINE AND CHASSIS
TORO-FLOW II DIESEL MODELS

CAB,
ENGINE,
& CHASSIS
TRUCK SERIES
DLA/DLV-4000
EG-5500-6500 A /V
SG-5500 M /Y
HG/JG-7500A
HG/JG-7500V
HJ/JJ-7500A
RG-7500R
TG-7500 A /V
HJ/JJ-9500
TJ/W J-9500
ENGINE
ONLY
CAB
ONLY
MD-3215(1)
MD-3800
MD-2840
MD-3747
MD-3776
MD-3750
MD-99264(2)
MD-3215(1)
MD-3748
MD-3280
(1) MD-3214 H.D. WIRING

(2) MD-3356 ENGINE AND CHASSIS WIRING
SERIES 53, 71, and CUMMINS DIESEL MODELS

HV/JV-7500
TV-7500
C H /C I-9500
H I/J I/M H /M I-9 5 0 0
HN/JN-9500
D C /D N /FC /FN -9502
D H /D I/F H /F I-9 5 0 2
(1) MD-3243 H.D. WIRING
MD-3750
MD-3282(1)
MD-3749
MD-3749
MD-5264
MD-5569
MD-5281
CHASSIS
ONLY
GRD.-CAB(ALL MODELS)
dash
i|
GRD.-ENONE-FRAME MTD. BAT.
tra m s
||-
[XJAL-6V BAT.-FRAME MTD.

SM/SS55000, SM 65000
R P O . .^ 7 7
SINGLE-12V. BAT.-FENDER MTD.

E M4500/ 5500M, SM/SS 5 5 0 0 0 ,
SM65000
SINGLE-I2V. BAT.-FRAME MTD
STARTER
STAR TER ASM.
HORN
AMMETER
GENERATOR
LOAD PICK-UP
( ftEF. FOR BODY BUU nFRS )
IGNITION-GAS MODELS
CONTROL SWITCH
LIGHTING
DIRECTIONAL- HAZARD 8
STOP LIGHTS
BRAKE WARNING T. T.
SCHOOLBUS ( VAC.)-STD.
F. B.C.-R.RO. JL4
TEMPERATURE ,GAMCE
FUEL GAUGE
Cab, Engine, and Chassis WiringEM-4500-5500M; SG-5500M/Y; SM-5500-6500M/Y ; SS-5500MMD-2840

(See Opposite Side for MD-3214)
ALARM BUZZER
SCHOOLBUS (AIR)
MODELS- S.TD^
LOW VAC. BRAKE
ALARM BUZZER
SCHOOLBUS (VAC.)-STD.
F. B.C.- R.RO. J L 4
BACK-UP LPS.
-t4 0 K .e m . ------- CD --------------------------------- --2 SPEED AXLE ( WHEN USED )
TmI.
I
eBLK.tRBBEOf K - J N i 'W T H ;
^12 9LM.
SPEEOO. ADAPTER
CIRCUIT
IDENTIFICATION
--------------
LW -
14 BLK.
S 8 L K ( P L A IN ) ------------
A X L E SHIFT SW.
Ua_._,____
AXLE SHIFT MTR.
LEGEND
SYMBOL
JUNCTION
GO
8 WAY M U L T IP L E
CONNECTOR
d H
C ONN ECTOR -
I 3 /
3 WAY M U LTIP LE
CONNECTOR
- INSTR. PANEL HARN. TO ENG. H AR N. ( GAS M O D E LS )
C E7
3 WAY M U LT IP LE
CONNECTOR
-IN STR . PANEL H A R N .-
I 3 /'
3 WAY M U LT IP LE
CONNECTOR
-ENG. H AR N.-
C D
3 WAY M U LT IP LE CONNECTOR
) 2 (
2 WAY M U LTIP LE
/B\
8 WAY M U LTIP LE CONNECTOR
O D
2 WAY M U LTIPLE
2 WAY M U LT IP LE CONNECTOR
-IN STR . PANEL HARN. TO EN G .H AR N.
- INSIDE CAB-UNDER IN S TR . PAN EL-UPPER R.H. SIDE
TO S T A R TE R INTER LO C K H A R N . ( D IESEL M O D ELS )-
ENG. HARN. TO HD.LR 8 PARKIN G L P HARN.
CONNECTOR
IN S TR . P A N EL H AR N. TO DIR. SW. H A R N .-
-A XLE
SHIFT SW. CABLE
TO A X L E
2 WAV M U LTIPLE
- UNDER
INSTR. PANEL AT STEERING
COLUMN
SH IFT MOTOR C ABLE

-INSIDE CAB-R.H. R E A R
-PART OF INSTR. PA N E L HARN. ( REE FOR BODY

I 2 <
-AT H E A D L A M P ASM.
C O NN ECTOR -
SIDE
B U IL D E R S ) -
CONNECTOR
H D
2 WAY M U LT IP LE
CO NN ECTO R -------
fH
^ U N C TIO N
[o]
JUNCTIO N BLOCK ( FU SIBLE
SINGLE LIN E C O N N E C T O R ------------
B LO C K ! LOA D PlC K-UP
LIN K )
TERM . OR CONNECTOR TER M IN A TIO N
SP LIC E ------------------------------
LINE FUSE-
- P A R T OF IN S T R . P A N EL H A R N .I REF. FOR BODY B U 'L D E R S )-
-A T R E A R
TAIL
B A C K -U P
- REE FOR BODY B U IL D E R S ----------------- -----------------
-IN S ID E CAB -D A SH
R E L A T E D
C IR C U IT S -
------------- ENG. C O M P A R T M E N T - D A S H
-R E LA T E D
C IR C U IT S
CIRCUIT
PRO TECTO R FOR A M M E T E R
=AN EL~ N EAR
LF? ASM.
FU SE
PANEL
PANEL
-AT 10 WAY M ULTIPLE C O NNE C TOR
-FUSE B L O C K -PART OF INSTR. PANEL HARN. ASM .

CIRCUIT B R E A K E R -
BROKEN LIN E S 8
SP ECIFIED R.PO. DENOTE WRG. 8 PARTS OTHER THA N
STD, 8 NOT IN STD. WRG. HARN. A S M S,
BUS BA R PA RT OF FUSE B L O C K - F U S E BLO CK PART OF INSTR. PA NEL HARN. ASM .
7-6354
BATTERY
ENGINE
GRD.
AMMETER - R.PO. 1275 U 31
STARTER ASM.
S TA R TER
VOLTMETER-R.P.0.-I267 UIO
GENERATOR
CONTROL SWITCH
IN S T R U M E N T S
LOW AIR A L A R M B U ZZE R

R.P.0.-0508
J83
ENGINE ALARM R P 0 .X 5 4
R. P. 0.-06 0 6
HORN
LtGHTMG
M A R K E R L IG H T S
TRL.I.C.C.MKR.LP RELAY
USE WITH SEMI T R L
BRKE.CONTROL R.PO.-J9I
R .P 0 .- 0 5 4 0
c a b le
R .P 0.-U 85-U 87
R .P 0 .- I2 0 3 - I2 0 4
t r a il e r
DIRECTIONAL*HAZARD 8
STOP LIGHTS
ELEC .2SPD A X L E
(WHEN USED)
AXLE
18 L T .G R N ^ C ID---- IQ B LK .
BACK- UP L PS
J-------16 BLK. ------------ /4 7 -
I6 B L K . -------------- B L K r
S H IF T
M TR.
R.H.
-16 LT. G R N 7
BACK
UP L PS.
i e L T .6 R N . - a ---- 18 BLK-
BACK U P LP. SW.
16 Y E L L ,
; P .H .2 S P D . W/S
U /IPE R M T R .
]
I
o HI.
1 OFF
16 BLUE WHT.CR.TR,
cJ hTJ
DUAL SPD. W/S WIPER

& WASHER
L.H 2 SP D
W/S Wl PER 4
W A S H E R SW.
-V flO -
W A S H E R ASM
O H
O FF
LO.
16 B L U E
W H T .C R .T R .
L.H. 2 S P D .
W/S W IP E R
& W A SH ER SW.
EM ERGENCY A IR BRKE.
R.P.O- 0 5 3 0 -J 75
16 P IN K
16
P /N K
16 P I N K . --- ---------------
~7J
EM ERGENC Y
S T O P LP. SW.
H EATER
- {4B LU EW H T. CR. TR.
>->
R E S IS T O R
HTR.
IA O R A N G E
1 BLOWER M TR .
HEATER BLOW ER
C O N T R O L SW.
2.5 A
RADIO RRO. 1276 - U 60
s '
t>---------
radio
Cab , Engine, and Chassis H.D. Wiring-DLA/DLV-4000; TG-7500A/V-MD-3214
LEGEND
CIRCUIT
IDENTIFICATION
JUNCTION
SYMBOL
T H R U * 3 ) --- -------------------- -
3 POST J U N C T IO N 0
12 P O S T JCT. B LO C K L.H. ( * \ T H R U * I2 )----------------
12 P O S T JCT. BLOCK R. H f I THR l/ l2 ) W IR ES WITH RED S L E E V E -
6 PO S T J C T BLOCK
(\
T H R U 6 ) ---------------------
LOCATION
FUNCTION
ENG . H ARN
ON C O N TR O L
TO S H IF T SW. TO MTR. C A BLE A S M .
INSTR, PANEL HARN.TO ENG. HARN. -D O M E LR

W IR E ASM . 4 T R L. W RG .HARN.
T R L .W R G. H A R N .T O
P N L. SUPT. FRT. S ILL BR K T .
CAB JCT. BE LO W FLO O R AT LH.FRT. S T E P
UNDER
T R L .C A BL E A S M .
IN L A N D
CA B AT C A B
R IS E R
REAR
e WAY MULTIPLE CONNECTOR TO 2 4 WAY CONNECTORS - INSTR. PANEL HARN.

TO HAZARD LT. WARNING SW.
------------------- U N D E R IN S T R .P A N E L AT ST EER IN G COLUMN
; WAY MULTIPLE CONNECTOR TO 2 - 4 WAY CONNECTORS - DIRECT SW ASM.
^47
4 WAY MULTIPLE CONNECTOR -
IN STR.PAN EL HARN.TO ENG. ALARM HARN. -
CD
3 WAY M ULTIPLE CONNECTOR -
INSTR. PANEL HARN.TO HD.LR 8 PARK.LP. HARN.
Z I7
\4/
4 WAY MULTIPLE CONNECTOR-
- STOP-TAIL LPFRT.EXT.HARN.TO REAR STOP-TAIL L P. HARN.-
<Z>
2 WAY MULTIPLE C ONNECTOR -
- REAR STO P-TAIL LPHARN.TO STOP-TAIL LR A S M .------------
[3]
3 WAY M U LTIP LE CONNECTOR -
- V O LT M E T E R WRG. HARN. TO INSTR. PNL. H A R N .----------
2 WAY MULTIPLE CONNECTOR
-------- ENG. HARN.TO AXLE S H IF T M TR .C A B L E
Q ]
----- L .H .F R A M E RAIL AT F R T .A X L E
ENG. HARN.TO STOP-TAIL LP FRT.EXT. HARN.
FU SE ---------------------------CIRCUIT BREAKER -------Cn
BELO W FLOOR AT L H, HD.LP. ASM .
-----------
L.H. FRAME RAIL AT REA R AXLE
-------------- AT STO P TAIL LR ASM.

UNDER
INSTR. PANEL AT
S T E E R IN G
COLUMN
-------------------------------------------- L .H .F R A M E AT B A C K OF C A B
FU SE B LO C K - INSIDE CAB
AT FUSE BLOCK - INSIDE CAB
L.H . SIDE COWL PANEL

L H. SIDE COWL PANEL
SING LE L IN E CONNECTOR
TERMINAL OR CONNECTOR TERMINATION

R E L A T ED CIRCUITS
S P L IC E ---------:---------------------------------------
LINE FUSE
---------------- BROKEN LINES 9 SPFCIFlED R.P.O. DENOTE WRG.ft PARTS OTHER THAN STD.S NOT IN STD.WRG.HAR n .ASM.
BU S
B A R P A R T OF FUSE B L O C K - - FUSEBLOCK PART OF IN STR.PANEL HARN. ASM.
T-5261
B A TTE R Y
ENGINE GRD
AM M ETER-R.P0.-I275
*' o o b lk
t r a n s . i|f r "
U3I
STARTER
- j| i
fram e
STARTER ASM.
VOLTMETER-R.P.0.-I267 UIO
HORN
GENERATOR
CONTROL SWITCH
INSTRUMENTS
LOW AIR A L A R M BUZZER

R.P. 0.-05 0 8
J83
ENGINE ALARM RPQ.X54

R.P. 0-0606
LIGHTMG
DIRECTIONAL-HAZARD 8
STOP LIGHTS
DUAL SPD W/S W IP E R a

W ASH ER
L.H.
SPD. W/S WIPER

MTR.S \MASCR ASM.
HEATER
HTR
- C 3 '7)3 0
BLOW ER MTR
h t r .blo w er
C O N T R O L SW.
18 BLK. ----- R>
BACK-UP LPS.
>16 WHT.-------- -------- 0
BACK-UP LPS.
-16 B L K ( P L A IN Y
16 B LK [R/BBED)8ACK-UP
- 18 BL K . ------ L.H.
LR SW.
------- M G P f i - -
2 SPEED AXLE ( WHEN USED)
- 0 > - '
'K - - ^
/6BLK
s- ^cd -14 RED
14 B L X . - a --- I4BLK-
--------------- M GRN -
16 DK G#N
1 %;
(T )------14 DK C R N -------------j'\
\--l2 B
L K.
. - -, ^
I\--IZ
BLK
*6 B L K --- -------------- |l SPEEDO. ADAPTER

------ 16 B L K
AXLE SHIFT MTR.
------------------------ (T | ------14 B L K --------
A X L E SH IFT SW.
rRADIO-R PO 1276
I'J '
U 60
RADIO
--------- 16 YELL
~ f6W H T
EMERGENCY
STOP LP SW.
I SA
------ 16 PINK
----- ^
---------------- 16 P IN K
-------
EM ERG ENC Y AIR B R A K E

R.P.0.-0530
J 75
--------- ----- 2 0 P IN K -- ----------
---
--L O W A IR
P R E S S SW
Cab , Engine, and Chassis Wiring-DLA/DLV-4000; TG-7500A/V-MD-3215

CIRCUIT
IDENTIFICATION
A IR PRESS
W ARNING LT.
LEG EN D
SYMBOL
JUNCTION
03
8 WAY M U LTIP LE CONNECTOR (b l k )
[]
8 WAY m u l t i p l e c o n n e c t o r ( w h t )
IN S T R . PANEL HARN.T0 ENG. HARN.
C A B JCT. B E L O W F L O O R
<!>
2 way
M ULTIPLE c o n n e c t o r ---------
AT
L .H.F RT ST E P Rl SER
-IN S T R .P A N E L HARN. TO DOME L P W IRE ASM
I WAY M ULTIPLE CONNECTOR TO 2 4 WAY CONNECTORS - INSTR. PA NEL HARN.

TO HAZ ARD LT. WARNIN G SW.
8 WAY M U LTIP LE CONNECTOR T O 2-4W AY C ONNEC TORS - DIRECT SW ASM.
U N D E R IN S T R . P A N E L AT S T E E R IN G
\ AJ
IN S T R . P A N E L HARN.TO ENG. A L A R M HARN.
C35
INSTR, PANEL HARN.TO HDLP 8 PARK LP HARN.
A WAY M U LTIP LE CONNECTOR \ 4/
4 WAY M U L TIP L E C ONNEC TOR -
- STOP-TAIL LP FRT E XT. H A R N .T O R E A R S T O P - T A IL L P HARN.-
2 WAY M U LTIP LE CONNECTOR ~
-REAR STOP -T A IL LP HARN.T O STO P -TA IL LP A S M . --------
(? )
2 w a y M ULTIPLE CONNECTOR -
2 WAY M ULTIPLE C ONNEC TOR
o^n^ _^P
- B E L O W F L O O R A T L.H H D L P
ENG. HARN.TO S TO P -TAIL L P FRT EXT. HARN,
axle
S h i f t s w . f e e d h a r n .t o a x l e s h i f t s w . h a r n
- A X L E SH IFTSW , HARN ,T0 AXLE SHI FT MTR. C A BL E -
F U S E ------------------
ASM.
--- L.H, F R A M E R A IL A T . F R T A X L E
L . H . F R A M E R A IL A T R E A R A X L E
---------
AT S T O P - T A IL LP ASM .
CAB JCT. BELO W FLO O R AT L.H. F R T S T E P R IS E R
------------- :------- L .H .F R A M E
--- FU S E B L O C K - IN S ID E CAB
C IR C U IT B R E A K E R
C O LU M N
AT FUSE
BLOCK - IN SIDE CAB
AT B A C K OF C A B
L . H . S ID E C O W L P A N E L
L H. SID E C O W L P A N EL
SING LE LIN E CONNECTOR
TE R M IN A L O R CONNECTOR TERM INATION

R E L A T E D C IRC UITS
SPLIC E ----------------------------
L IN E FUSE
---------- B RO KEN L IN E S 8 SPECIFIED R.P.O. DEN O TE WRG a P A hT S O TH E R THAN STD S N O T IN STD WRG HARN ASM.
BUS
BAR P A R T OF FUSE BLOCK
FUSE BLOCK PART OF IN STR,PANEL HARN. ASM
1-5262
B A TT E R Y
ENG GRD
AM M ETER -R.PO. U3I
STARTER
VOLTMETER-R.PO. UIO
S T A R T E R INTERLOCK
S T A R T E R IN TE R LO C K WITH
AUTO TR A N S
R.RO. M 4 5
GENERATOR
CONTROL SWITCH
INSTRUMENTS
LOW AIR A LA R M BUZZER
ENGINE ALARM R PO X54
HORN
LIGHTING
TRL IC.C.MKR. LP RELAY
USE WITH SEMI TR L
BRKE CONTROL R.RO.J9I
TRAILER CABLE
R .P O -U 85-U 87
DIRECTlONAL-HAZAPfD 8
STOP LIGHTS
ELEC.2SPD- A X LE
(WHEN USED)
LT G R N m 3---- /8 B L K
BACK-UP L P S .
- q j T w 6 BLK -
ft.H
-57-
BACK UP LPS
18 LT G R N ---C D ---- 18 B LK fS^ lt, L H
BACK U P LP.SV*.
S E R IE S
- o T n n r
P.H 2 S P D W/S
SHUNT
R.H. 2 SPD
I o HI
w /s WIPER
SW. '
I O fF
W IP E R M T R
- f in m p
-16 BLUB WHT CR.TR.
PAWL
DUAL SPD W/S WIPER

& WASHER
RATCHEuK
I L.H 2 SPD
W/S W l PER 4
rr;
W A S H E R ASM
S E R IE S
WASHER SW.
L.H. 2 SPD
w/s
W IPER
| 0 HI.
I O FF
WASHER SW.
Lss LO.
I6 B L U E
IGN
16 p / m<-
EMERGENCY AIR BRKE

R.RO. J 77
WHT.CR.TR,-
--- 16 WHT ---
14 ORANGE
--
- /6 WHT
P IN K - C D ---- IS P IN K C ^ S b ------ --------- 16 P I N K ----- ---------- o i o
ir,w
I6 W U T
LOW P RESS 4
EMERG. STOP
LP- SW.
HEATER
LOW P R E SS & EMERG,
------ -------- 2 0 B R N
^ ^ 1,1
BRAKE W A R N IN G LP.
14 B LU E W H T C R TR
14 O RANG E
BLOWER MTR
H E A T E R BLO W ER
C O N T R O L SW.
RADIO R.RO. U 6 0
o\ ^y
j o]
---------------- 16 YE LL -
i RA0|
R A D IO
t
CIRCUIT
IDENTIFICATION
LEGEND
12 P O S T J C T
[Q j
12 P O S T JCT BLOCK R. r t f I THR i f 12 ) W IRES WITH RED S L E E V E ->
o>
6 PO S T J C T BLOCK ( " \ T H R U 6 ) --------------------
rn
BLO C K L H
LOCATION
FUNCTION
JUNCTION
SYMBOL
I THRU 12 )-------
TR L W R G
INSTR. PANEL HARN.TO ENG HARN. DOME L P

WIRE ASM i TR L WRG HARN.
CAB J C T BELO W FLO O R AT LH FRT S T E P
H A R N TO TR L C A B L E A S M
U N D E R CA B AT CA B REAR
R IS T E R
8 WAY MULTIPLE CONNECTOR TO 2 4 WAY CONNECTORS - INSTR. PANEL HARN.-.
L TO HAZARD LT. WARNING SW.
CQ
U N D ER IN S T R .P A N E L AT STEER IN G COLUMN
8 WAY MULTIPLE CONNECTOR TO 2-4WAY CONNECTORS - DIRECT SW ASM .I
3
<D
>
Q3
Q .
a:
b
\ J
IN S T R .P A N E L HARN.TO ENG. A LA R M H ARN.
05
INSTR. PANEL HARN.TO HDLP 8 PARK LP HARN.
- STOP-TAIL LP FRTEXT.HARN. TO REAR STOP-TAIL L P HARN.
CD
2 WAY M ULTIPLE C O N N EC TO R-
-REAR S T O P - T A IL L P HARN.TO STO P -TAIL L P A S M . --------
g]
3 WAY MULTIPLE
-VOLTMETER WRG. HARN. TO INSTR. PNL. HARN ---------
CONNECTOR-
o ^ \^ p
-------
ENG.HARN.TO AXLE S H IF T M T R , C A B L E ----------
F U S E ---------------------------CIRCUIT BREAKER --------
i i
BELOW FLOOR AT L.H. H D L P ASM.

----- L.H .FR A M E RAIL AT FR T A X LE
ENG. HARN.TO STOP-TAIL LP FRT EXT. HARN.
4 WAY M U LTIP LE CONNECTOR-
fT l
(Q
->
L.H. FRAME RAIL AT R E A R A X L E
----------
UNDER
INSTR. PA N EL
AT
AT STO P TAIL LPA SM .
S T E E R IN G
COLUMN
------------------------------------------- L.H .FRA M E AT B A CK OF CA B
FU SE BLOCK - INSIDE CAB


L .H . SIDE COWL PANEL
S IN G L E L IN E C O N N E C T O R
th
T E R M IN A L OR CONNECTOR TERMINATION
RELATED CIRCUITS
S P L IC E
----------------------------
R J ^ > LINE FUSE
Co
to
CO
---------------- BROKEN LINES S SPECIFIED R.P.O. DENOTE WRG ft PARTS OTHER THAN S T D S NOT IN STD WRG HARN ASM.
*
BUS
B A R P A R T OF FUSE BLOCK - FUSE BLOCK PART OF IN STR,PANEL HARN. ASM.
T-5266
16 -fi~51 /
TRANS. ' if
F RAME
T-6355
/& jTsj !&
BACKUP LAM PS
GENERATOR
ENGINE CONTROL
CONTROL SWITCH
GAUGES-W ARNING
T ELL-TA LE S - ALARM
B U Z Z E R - HR.M ETER
BRAKE INTERLOCK
A C C E S S O R IES
DIRECTiONAL-HAZARD
8- STOP LIG H TS
CIRCUIT
IDENTIFICATION
TERM. C A V ITY *1 T H R u l6
TERM. JC T.STU D -IN N ER L.H.
TERM. JCT.STUD-OUTER R.H
8 VVAY M U LT IP LE CONNECTOR
3 WAY M U LTIPLE
(2 j
2 WAY M U LTIP LE C O NN ECTO R J
<T)
3 WAY M U LTIP LE
>
X
cC\j>
C O NNECTO R ---- -
12 POST JCT "l TH Ru'l2---------- n
CD
*
--- - AT R.H. H E A D L P
ASM.
-INSTR, PANEL HARN TO TRANS. S H IF T C O NTR O L ASM .
---- UN D ER IN S T-i.PAN EL AT TRAN S S H lc T C ONTROL ASM
- IN STR ,PA N E L HARN.TO CHASSIS WNG. H A R N .--------- -
------------------------- INSlO E CAB AT R.H.REAR SIDE
CIRCUIT B R E A K E R - M ANUAL RESET
F U S E -----------------------------
-------- FUSE BLOCK IN GLOVE BOX C O M P AR TM EN T
L IN E FU SE
O T E R M IN A L OR CONNECTOR TERM INATION
UNOER INSTR. PA N EL AT ST EER IN G C O LUM N
CONNECTOR
C IR C U IT P R O T E C T IO N FOR AM M ET ER
UNDER INSTR, PANEL ON ST E E R IN G COLUMN S U P T
L.H.S
AT I8W A Y M U L T IP L E CONNECTOR IN ENG COM PA RTM EN T ON DASH P A N E L-U P P E R R.H S ID E

---- :------------------------------------------------------------------ - R E LA T ED CIR CUITS
S P LIC E
S IN G L E L IN E C O N N E C T O R ------------BUS BAR PART OF FU SE B L O C K - F U S E BLOCK PART OP IN S TR . PANEL HARN.ASM.
------- BR O KEN LIN E S DENOTE
BODY CIRCUIT WRG. & PARTS OTHER THAN STD.
Cab, E ngine, and Chassis WiringH M - 8 7 2 1 B - M D - 3 2 4 4

(See Opposite Side for M D-3280)
o o b u <.: - ^ | i
DUAL- 6 V BAT- FRAME MTQ

(STD-GAS MODELS)
DUAL-12V BAT-FRAME MTD

(R.PO. 12 7 3 -DIESEL MODELS)
SINGLE-12V BAT-FRAME MTD.

(STD.-DIESEL MODELS)
(R.PO. 1 2 7 4 -GAS M O DELS)
ENG. GRD ALL MODELS TRANS.
AMMETER-R.PQ-1275
STARTER
VOLTMETER-RPQ-1267
GENERATOR
STARTER
CONTROL
IGNITlON-fGAS MODELS)
CONTROL
SWITCH
INSTRUMENTS
LOW AIR ALARM BUZZER

(R .P Q - 0 5 0 8 )
(STD.-DIESEL)
ENGINE ALARM
R. P. 0-0606
HORN
LIGHTMG
TRL I.C,C, MKR LP RELAY
USE WITH SEMI TR L
BRKE CONTROL R.PO. 0 5 4 0
TRAILER CABLE
R.PO-1203-1204
DIRECTIONAL-HAZARD a
STOP LIGHTS
D IR E C T IO N A L
F LASHER
E LEC .2SPD A XLE

(.WHEN USED)
7 Y /6 e L K - o O F T ^ ;
SPEE DO A D A P T E R
b-tZ
A X L E S H IF T
M Tf
-14 B L K -- - t D /2 SM O O TH
It lA X LE
S H IF T SW.
-12 BRN -BLK Tft.

I S L T G R N t t ---- IQ B L K
BACK- UP LPS.
BLK
R.H.
BACK UP LPS
-16 B L K ------ 2 3 7 I8 L T Q R N
SACK U P LP. SW.
C D ---- /8 B L K
UH.
t6 Y E L L
O ff
I O HI
1 OFF
3 ^%
/ BL U E
W HTXR.
Tf\.-
DUAL SPD W/S WIPER

& WASHER
L.H a SPD.
W/S WJ PER &
W A S H E R SW
W A S H E R ASM
rflO -
O HI
OFF
LO
16 BLUE W HT CR.TR.
L . K . 2 S PD
W/S W IP E R
4 W ASHER SW
H EATER
-14 BLUE W HJ CR TR
HTR
BLOWER MTR
H E A T E R B LO W ER
C O N T R O L SW
2.5 A
RADIO RP.0. 12 76
-i l. C Z jo i
G l y - 'O -
Iraoi
LEGEND
CIRCUIT
IOCNTIFICATION
Cab, Engine, and Chassis W iring-TE/TJ/W E/W J-9500-MD-3280
SYMBOL
H]
3 WAY MULTIPLE
12 PO ST JC T
c o n n e c t o r -------------------------
-VOLTMETER WRG HAHN TO INSTH r>NL H A t N
UNDER INSTR PANEL AT STEERING
COLUMN
BLOCK L.H (*\ THRU*I2)-----------------------INSTR. PANEL HARN.TO ENG. HARN. DOME LP

WIRE ASM t TRL WRG HARN.
12 PO ST JCT BLOCK R.h (* I TH R lfl2 ) WIRES WITH RED S LEEV E -
LOCATION
FUNCTION
JUNCTION
6 POST JC T BLOCK ("*1 THRU 6 ) -------------------------------
TRL WRG HARN TO TRL C A BL E ASM
CAB JC T BELOW FLOOR AT LH FRT ST E P R IST ER
UNDER CA B AT CA B REAR
8 WAV MULTIPLE CONNECTOR TO 2 - 4 WAY CONNECTORS - INSTR. PANEL HARN-,

L TO HAZARD LT. WARNIN&SW.
8 WAY MULTIPLE CONNECTOR TO 2 - 4 WAY CONNECTORS - D IR E C T S * A S M .-I
U N D ER IN S T R .P A N E L AT STEER IN G COLUMN
^47
INSTR.PANEL HARN.TO ENG. ALARM HARN. -
CD
i WAY MULTIPLE CONNECTOR -
INSTR. PAN^L HARN.TO HOLP & PARK LP HARN.
{* ]
\4 /
- STOP-TAIL CP FRT EXT. HARN.TO REAR STOP-TAIL L P HARN.
CD
-REAR STOP-TAIL LPHARN.TO STOP-TAIL LP A SM .------------
3 POST
ENG. HARN.TO STOP-TAIL LP FRT EXT. H A R N -
JUNCTION ( I THRU 3)-
EIJG
J U N C T I0 N ( * 7 T H R !J * 9)-
HAHN
TO A XLE SHIFT MTR CAFI E A S M - ---------
-KNC, H A f* T O S H IF T SW T O v * R
CABLE ASM-
FUSE ------------------------------
----- L .H ,F R A M E RA IL AT FR T A X LE
L.H. FRAME RAIL AT R E A R AXLE
-------------- AT ST O P-T A IL LP ASM.
ON i:,;.ip t L.H. F R A M E - A T
flN C O N TRO L
REAR OF CAB
INLAND PNL. SUPT. FRT. S IL L BRKT.
------------ FU SE B LO C K -IN SID E CAB
CIRCUIT BREAKER I I
-BELO W FLOOR AT L .H .H O L P ASM.

L .H . SIDE COWL PANEL
SINGLE LINE CONNECTOR

TERMINAL OR CONNECTOR TERMINATION
RELA T ED CIRCUITS
SP L IC E ------------------------------------------------
R J ^ > LINE FUSE

---------------- BROKEN LINES B SPECIFIED R.PO. DENOTE WRG S PARTS OTHER THAN STD S NOT IN STO WRG HARN. ASM.
T-5268
*
BUS BAR P A R T OF FUSE BLOCK
FUSE BLOCK PART OF INSTR. PAN EL HARN. A S M .
B A T TE R Y
AMMETER-R.R0.-I275
U3I
STARTER ASM.
STARTER
VOLTMETER-R.P.0-1267 UIO
HORN
GENERATOR
IGMTION
CONTROL SWITCH
TAC H O M E TER-R.P.0.1269
(IN L IN E 6 CYL.ENG.'l
LOW AIR A L A R M BUZZER

R.P. 0 .- 0 5 0 8
J 83
ENGINE ALARM R P 0 .X 5 4
R.P. 0 .- 0 6 0 6
LIGHTING
STOP LIGHTS
DUAL SPD W/S W IP E R a

W ASH ER
H EA TE R
-t=y- ''T 5 T x - c f
H TR. BLOW ER
CO NTRO L
HTR
-18 BLK. ------ @ H l .
R>
BACK-UP LPS.
( a-7 --- 16 LT. G PN-
- 16 B L K (P ^ A IN )-
<>6 W H T ---------- [ p j- 16 B L K { R IB B E D ) BACK-UP

LR SW.
BACK-UP LPS .
b lo w e r m tr
SW.
16 P IN K
----- 14 C R N . ------- ---------------------14 C RN -
, U > ,7VK
-14 P
I N
I4 P IN K - -(a )-
- ! D K G R N -------- Q -
I6 B LK __ ^_\^J~?63LK ---------------------- 1> SPEEDO.

DO. ADAPTFR
ADAPTFR
-03-/4 RED -
-I6 D K G R N ------- j - O T r * ' T i y > | ;
;
;
12 B
L
L K
. - |
AXLE SHIFT MTR.
------------------ G D ----- 16 B L K
'*L0~/4 BLK~ C3 --->4BLK- - * ---------- I6 8LK
t i * ____________ j
AXLE SHIFT SW.
RADIO-R PO 1276
U 60
1 "
_
----- q
- / e WHT
I
T>-i
I5A
^'o---------------- 16 P IN K
EMERGENCY
STOP LP SW.
EM ERG ENC Y AIR B R A K E

R.P.0.-0530
J 75
----- ----- 2 0 P IN K -
----------- 2 0 8 R N
LOW AIR
P RESS SW
-2 0 BLK
i!'
A IR PRESS
W ARNING LT.
CIRCUIT
IDENTIFICATION
LEG EN D
n
Q
C~
3
<Q
5*
ra
8 WAY
H]
rn
El 8
m u l t i p l e CONNECTOR (BLK)
INSTR. PANEL HARN.TO ENG. HARN.
WAY M U L T IP L E C ON N EC TOR (W HT) C A B JG T . B E LO W FLOO R
<|>
2 WAY M ULTIPLE C O N N E C T O R -------
AT
L ,H.F RT S T E P R IS E R
- IN S T R :P A N E L HARN. TO DOME L P W IRE ASM
I WAY M ULTIPLE CONNECTOR TO 2 -4WAY CONNECTORS - INSTR. PA NELHARN.-
L TO HAZARD LT. WARNING SW.
Q .
8 WAY M U LTIP LE CONNECTOR T O 2-4 WAY CONNECTORS - DIRECT SW A S M .I
U N D E R IN S T R . P A N E L A T S T E E R IN G
COLUM N
3-
Q
V)
\ 4/
IN S T R .P A N E L HAWN.TO ENG. A L A R M HARN.
CD
INSTR, PANEL HARN.TO H D LP SP A R K LP HARN.
</>
3
CQ
</> r 1
ft> ; >
o
^
O
M
<D
CO ^
O i
/4 7
\ 4/
4 WAY M U L TIP L E C O N N E C T O R -
* S T O P -T A IL LP FR T E X T.H A R N .TO R E A R S T C P - T A IL L P HARN.
L.H. FRAME RAIL AT R E A R A X L E
3D
2 WAY M U LTIP LE C O N N E C T O R -
REAR S T O P - T A IL L P HARN.TO STO P -TA IL LP A S M .--------
--------- A T S T O P - T A IL LP A SM .
(2)
2 WAY M ULTIPLE C O N N E C T O R -
CT\
2 WAY M ULTIPLE C ONNEC TOR
or" ' V
ENG. HARN.TO STO P -TA IL L P FR T EXT. HARN.
A X L E SH IFTSW . HARN.TO AXLE SHI FT M i R, C A B LE
F U S E -------------------
SING LE L IN E C O N N E C T O R ----------------- -------- -
T E R M IN A L O R CONNECTOR TERM INATION
? o
NO 2
------------- :------- L .H .F R A M E
----------------
--
------
AT B A C K OF C A B
L .H . S ID E C O W L P A N E L
L .H. S ID E C O W L P A N E L
-------
---------------------------------------------------------------
R E L A T E D C IRC U ITS
oo
CAB JCT. BELO W FLO O R A T L.H. FRT. S T E P R IS E R
F U S E B L O C K - IN S ID E CAB
C IR C U IT B R E A K E R -------------------------------------------------------------------------------------
I i
--- L .H . F R A M E R A IL A T F R T A X L E
A X L E SH IFT SW. FEED HARN.TO A X L E SH IFTSW . HARN,
NO
- B E L O W F LO O R A T L.H. H D L P A SM .
S P L IC E -------------- ------------------------------------------- ----------------------------
----- -..
b L IN E FUSE --------------------------------------------------------------------------------------------------
-----------BRO KEN L IN E S 8 SPECIFIED R.P.O. DENOTE WRG a PARTS O TH E R THAN S T D S N O T IN STD WRG HARN ASM.
BUS
B AR P A R T OF FUSE BLOCK - FUSE BLOCK PART OF INSTR,PANEL HARN. ASM,
T-5269
BATTERY
ENG.GRD.
A M M E T E R -R.PO. U3I
'00 -ll. ENG.
STARTER
V O L T M E T E R - R.PO. UIO
S T A R T E R IN T ER LO C K
S T A R T E R IN T E R L O C K W ITH
AUTO T R A N S
R.R0. M 4 5
HORN
GENERATOR
CONTROL SWITCH
INSTRUMENTS
LOW AIR A L A R M B U ZZE R
ENGINE ALARM RPQX54
LIGHTING
r V H
zy- i8 P u R P L - ~ s <& J
R.H. STO P-TAtL

a d ir .lr
STOP LIGHTS
I88R //-C D -/88LK
L IC E N S E
I8 B R N X ? ~ )- I8 P U R P LF -
~
\ j/8 YFUtO D ---- I8BLK ^ 2 J
LR
L.H. STOP-TAIL
& D IR .LP.
O ff
R.H.
2 SPO w /S WIPER M TR
R.a
2 SPO w /S WIPER s w
18 L T BLUE
DUAL SPD W /S W IP E R
W ASHER
2 SPO W/S W R
MTR. a WAStCR ASM.
L.H.
! o *
2 SPD. W/S WIPER 8

WASHER SW.
K fl
I -OFF I
-16 YELL
HEATEft
HTR
BLO W ER M TR
HTR. BLO W ER
C O N T R O L SW.
18 LT. G RN .------ C D ------------ 18 BLK- --------- ( 3 ^
BACK-UP LPS
-16 PINK-1
2 SPEED AXLE ( WHEN USED )
._w----- 14 OK.GRN.------ C 3 ------------------------ >4 DK G R N ---------- -------/4 DK.
'ZD-14PINK
-I4PINK - -G)- J-^
LPS.
3 LT. G RN .--------CD -------- B LK .---------- L.H.
- 1 4 P IN K
14 PINK-
R.H.
BACK-UP
E
- I6 B LK [P L A IN ) -
- { 6 J - / 6 ' B LK {R iE B E O ) O ^ O BACK-UP
LR SW.
I6BLK ^ ^ y / 6 B L K - - J'^ f ^ - C > - - ^
C D -----14OK GRN.----------- j- - 0 ^ 't y '' I V ' i

I|- -/2B LK .---/t
SPEEDO. A D A P T E R
AXLE SHFT MTR.
14 B LK .-C ? 14BLK- - i ---------------14 B L K ----------------------------------------------- GO------- 14 BL K
"
AXLE SHIFT SW.
EM ER G E N C Y A IR
R.RO. J 77
BRAKE
f
--- , 4
C R IN G E
---- /' . H T
------
STOP L R
R ELA Y
-16 P I N K ----- q r>> ------
LOW P R E S S ,
E M ER G . STOP
LP. SW.
R A D IO
L .
-20BRN
, LOW P R E S S ,
EM ER G EN CY
(ITM ,:> BR A K E W ARN |NG LP.
c _ - 2 r;J
____ ji
R.RO. U 6 0
R a o ic
t
CIRCU IT
IDENTIFICATION
LEG EN D
SYMBOL
[g]
JUNCTION
8 WAY M U L T IP L E CONNECTOR (BLK)
INSTR. P AN EL HARN.TO ENG, HARN.
[|]
8 WAY M U L T IP L E C O N N E C T O R (W H T )
C AB JC T
<2>
B ELO W FLOO R
AT
L H.F RT S T E P R IS E R
IN S T R . P A N E L HARN. TO DOME L P W IR E ASM
2 WAY M U LTIP LE C O N N E C T O R ------
8 WAY M U LTIP LE C ONNEC TOR TO 2 4 WAY CONNECTORS - IN STR. PA N E L HARN.-,

L T O H AZAR D LT. W ARN IN G SW.
Q
CT
m
3*
^ 4 j
4 WAY M U L T IP L E C O N N E C T O R ---
IN S T R . P A N E L HARN .TO ENG. A L A R M H ARN .
C3)
3 WAY M ULTIPLE C O N N E C T O R ---
INSTR. PANEL HARN.TO H D LP S P A R K L P HARN.
IQ
UNDER
8 WAY M U L TIP L E CONNECTOR T O 2- 4W A Y C O N N EC T O R S - D IR E C T SW A S M , 1
A7
L.H. FRAM E RA IL AT R E A R A X L E
3-
GD
(D
REAR S T O P - T A IL L P H A R N .T O S T O P - T A IL L P ASM .
ASM.
--- L . H . F R A M E R A IL A T F R T A X L E
S T O P - T A IL L P F R T E X T .H A R N .T O R E A R S T O P - T A IL L P H A R N .-
4 WAY M U L T IP L E C O N N E C T O R
Q-
COLUM N
B E L O W F L O O R A T L.H. H D L P
ENG. HARN .TO S T O P - T A IL L P F R T EXT. H A R N .-------------
C O N N EC TO R
IN S T R . P A N E L A T S T E E R IN G
----------A T S T O P - T A IL L P A S M .
--------
(T]
A X L E S H IF T SW. FEED HARN.TO A X L E S H IF T S W . HARN.
------------
WAY M U LTIP LE C O N N EC TO R
orX ^ P
E N G . HARN.TO A X L E S H IF T M T R .C A B L E
CAB JCT. B E LO W F L O O R A T L.H. F R T S T E P R IS E R
--------------------- L .H . F R A M E
F U S E B L O C K - IN S ID E C A B
F U S E ---------------------
AT B A C K O F C A B
CO
I
I i
V I
O i
AT F U S E
C IR C U IT B R E A K E R --------
BLOCK - IN S ID E C A B
S IN G L E I IN E C O N N E C T O R
T E R M IN A L OR CONNECTOR TE RM IN ATIO N
R E L A T E D C IR C U IT S
L IN E FUSE
0
1
CO
to
_____________ B R O K E N L IN E S 8 SP E C IFIE D R.PO. D E N O T E WRG & P A R TS O T H E R TH AN STD 8 N O T IN STD WRG HARN ASM.
00
to
BUS
BAR P A R T OF FU S E BLOC K
FUSE BLOCK PART OF IN ST R .P A N E L H A R N . ASM .
1-5270
r
^
^
I 6V BAt . v , bat.i
D U A L-6V BAT.- FRAME MTD.
R.PO. T66CTM/WMS5000-80000)
L . --------- ----6 BLK (|<
FRAM E
B A TT E R Y
AM M ETER-R.R0.-I275
U3I
STAR TER
STARTER
VOLTM ETER-R.P.0.-I267 UIO
GENERATOR
(GMTION
CONTROL SWITCH
TA C H O M E TER -R .P.0.1269
(IN L IN E 6 CYL.ENG.)
LOW AIR A L A R M B UZZER

R .P .0.-0508
J83
ENGINE ALARM RP0.X54

R. P. 0 .- 0 6 0 6
HORN
LIGHTING
TRL I.C.C. MKR LF? RELAY
USE WITH SEMI T R L
BRKE CONTROL R.RO. J9I
R.PO. 0 5 4 0
TRAILER CABLE
R.P0.-U85-U87
R.P0.-I203-1204
STOP LIGHTS
ELEC.2SPD- A X L E
(WHEN USED)
ELEC.2SPD. A XLE
(WHEN USED)
1 A X L E S H IF T
M TR
(TM 8 5 0 0 0 - 80013)
/ IS LT G R N CZD
BACK-UP LPS.
back
up
lp
18 B L K
-16 LT GRN-
-/ u -
BACK
UP LPS
-18 LT G R N ---C D ---- 18 BLK-^'fty,;'
. SW.
-16 YELL
; f? H 2 S P D W/S
W IP E R
M TR
O FF
'i LC
cJ
- 16 BLUE WHT. CR.TR-
hti
DUAL SPD W/S WIPER

& WASHER
L.H 2 SPD
W/S Wl PER &
W A S H E R SW
W A S H E R AS^
OHI
O FF
LO
16 BLUE WHT. CR.TR.
L . H , 2 S PO
W/S W IP E R
& W A SH ER SW
-16 WHT --- ---------
1,
1E M E R G E N C Y
EM ERGENCY A IR BRKE
R.P.O. 0 5 3 0 -J 75
- 16 P IN K - T Z K
w 6
- 1 6 P IN K
P I N K ----------------S T O P LP SW
LOW All?
PRESS SW
2 0 P IN K
H EATE R
-14 BLUE WH T CR TR
~ 0->
- 20BRN
---
--
-2 0 B L K
R E S IS T O R
b-i|.
' BLOWER MTR
H EATER BLOW ER
C O N T R O L SW
2.5 A
RADIO R.RO. 1276 - U 6 0
1Rad io
----- 16 YELL
Cab, Engine, and Chassis WiringLA/LV-4000; TM-7500
RADI C
LEGEND
CIRCUIT
IDENTIFICATION
SYMBOL
JU N C TIO N
3 POST J U N C T IO N (# 1 THRU 3}
3 PO S T J U N C T IO N *1 TH R U * 3 ) ------------------------
12 P O S T J C T
B LO C K L H
LO CATIO N
FUNCTION
EN G
H A R N TO A X L E
ENG
HARN
S H IF T MTR C A B L E
- O N IN S ID E
ASM'
ON C O N TR O L
TO S H IF T SW TO MTR C A B L E AS M
12 P O S T JCT BLOCK
6 P O S T J C T B LO C K ( " l
IN L A N D
REAR
OF CAB-
PN L SU P T FRT
S ILL B R K T
( * \ T H R U I2 j----------------
- INSTR. PANEL HARN.TO ENG. HARN, -D O M E LP
i^ j
L.H ,F R A M E - A T
T H R U 6 ) ----------------------
C A B J C T BE LO W FLO O R AT LH FRT S T E P
R IS T E R
W IR E A S M 4 TR L WRG HARN .
R.h (* I THR m 2 / WI RES WITH RED S L E E V E TR L WRG
H A R N TO TRL C A B L E A S M
UNDER
CA B AT CA B R E A R
8 WAY M ULTIPLE CONNECTOR TO 2 -4WAY CONNECTORS - INSTR. P A N E L HARN.
I WAY M U LTIP LE CONNECTOR T O 2-4W AY C ON N EC TORS - DIR EC T SW ASM,
T O H A Z A R D L T W A R N IN G SW.
UNDER
I N S T R . P A N E L A T S T E E R IN G
C O LU M N
with H.D. Wiring; TM/WM-8500MD-3283

4 W A Y M U L T IP L E C O N N E C T O R
IN S T R .P A N E L HARN.TO ENG. A L A R M HARN.
CD
INSTR, PANEL HARN.TO H D LP 8 PARK LP HARN.
/Aj
\ 4/
4 WAY M U L T IP L E C ON N EC TOR
- STOP-TAIL LP FRTEXT.HARN. TO REAR STOP-TAIL L P HARN.
-- L.H. FRAM E RA IL AT RE AR A X L E
-REAR S T O P - T A IL LP H ARN .TO ST O P -T A IL L P A S M . --------
------------ AT S T O P - T A IL L P A S M .
<23
111
GO
E N G . H A R N .T O S T O P - T A IL L P
F U S E --------------
C IR C U IT B R E A K E R
BELO W
F R T EXT. H A R N .
-VOLTMETER WRG.HARN. TO INSTR, PUL. HARN.
2 WAY M U LTIP LE C O N N EC TO R
ENG. HARN.TO AXLE S H IF T MTR C ABLE
L .H . H D L P
ASM
---- L . H . F R A M E R A I L A T F R T A X L E
UNDER
IN STR. PANEL AT S T E E R IN G
COLUM N
------------------------- :-------- L . H . F R A M E
FUSE
FLO O R AT
AT F U S E
AT B A C K OF C A B
B L O C K - I N S ID E C A B
L . H . S ID E C O W L P A N E L
B L O C K - I N S ID E C A B
L . H. S ID E
C OW L PANEL
SINGLE L IN E CONNECTOR
T E R M IN A L OR CONNECTOR TERM INATION

R E L A T E D C IRC U ITS
S P L IC E -------- -----------------------
L IN E FUSE
-----------BROKEN L IN E S 8 SPECIFIED R P.O. D EN O TE WRG 8 PARTS O TH E R THAN S T D S N O T IN STD WRG HARN ASM.
BUS
BAR
P A R T OF FUSE BLOCK
FUSE HLOCK P ART OF IN STR.PANEL HARN. ASM,
T-5271
ASM .
COLOR
WHT - W H ITE
T = TAN
T-6356
REAR ELECT. EQUIP PANEL.

SYM
Y = YELLOW
(jR = GREEN
R = RED
K = BLACK
BL * BLUE
M * MAROON
N = NATURAL
CT = CROSSTRACER
TR = TRACER
/ / = PARALLEL
NOTES
DESIGNATED CIRCUIT FOR
~ \
*2 DESIGNATED CIRCUIT FOR

A VOLT. REGULATOR USED W IT H 61 AMP GEN. STD.
B VO LT REGULATOR USED
C M ASTER
a u x
W,TH-C X
CIRCUIT BREAKER
-7 0 A
90 A
S(S E E NOTE "\

(S E E N O T E " 2 )
CIRCUIT BREAKER
FRAME RAIL GROUND

- ALU CONNECTORS SHOWN
LOOKING INTO OPEN MATING ENDS
-
D O TTED
w ir in g
LIN ES
or
DENO TE
R.R
parts
CONNECTORS
Engine and Chassis WiringRG-7500RMD-3356
S YM
REAR
COLOR
K
m
co
o
ELECT. EQUIP PANEL
W H T = W H ITE
T = TAN
Y * Y E LLO W
OR * G R EEN
R = RED
B K =B L A C K
B L * B LU E
M * MAROON
N = NATURAL
CT = C R O SS T R A C E *'
I4-N-R-CT-397
TR = T R A C E R
/ / = PA RA LLEL
N O TES
- \
~2
DESIGNATED CIRCUIT FOR

DESIGNATED CIRCUIT
FOR
A VOLT. REGULATOR USED W IT H 61 A M R G E N . - S T D .

B V O L T REG ULATO R USED W I T H - C f ^ X
j70A
L 9 0 A
ge
'. ^
fS E E NOTE *1 )
(S E E N 0TE "2)
ENG
GEN.(SEE NOTE *2)
CONNECTOR -)f
Engine and Chassis WiringR M -7500R M D -33 57

(See Opposite Side for M D-3747)
>BLK.-------||i
Gfto.-CAB-ALL MODELS
ENGINE
GRD.-ENGINE
DUAL-6V BAT.-FRAME MTD.

R.PO. T66 GAS MODELS
SINGLE-12V. BAT.-FENDER MTD

{GAS MODELS-STD
SINGLE-12V. BAT-FRAME MTD
STARTER
STARTER ASM.
STARTER INTERLOCK
(DIESEL MODELS ONLY)
HORN
VOLTMETER-R.PO. UIO
AMMETER
WIRE WITH RED SLEEVE
GENERATOR
IGNITION-GAS MODELS
CONTROL SWITCH
TEMPERATURE GAUGE
FUEL GAUGE
DUAL FUEL TANK-R.PO. N07

( GAS MODELS ONLY)
ENGINE ALARM R.P0.X54
DIFFERENTIAL LOCK
TELL-TALE
( ALL TANDEM AXLE MODELS)
LIGHTING
MARKER LIGHTS
TRAILER CABLE
R.PO.-U85-U87
DIRECTIONAL-HAZARD S
STOP LIGHTS
L.H. STOP-TAIL
8 DIR. LP
2 SPD. W/S WIPER
2 SPD. W/S WIPER

a WASHER
M TR .a WASHER ASM.
18 BLK.-Cf^
BACK-UP LPS.
16 B L K - ----- [w]--- 16 L T. CRN.
>-
BACK-UP LPS.
>0)----- 16 LT. CRN.
BACK-UP
LR SW.
12BlK.tRG8ED)
2 SPEED AXLE ( WHEN USED !
S L E E V E -----
REAR
AXLE
SPtED O . A D A P TER
t BLK.------------
,------------^ ! ) --------------
r- O T 'O 'W S '^ - I ;
^ --I2 8 L K .--J ^
------------------------- 12 BLK. t SMOOTH) -
| +
')>-* | A XLE SHIFT MTR.
! <aJ-o^JULa
A X L E S H F T SW.
HEATER
H E A T E R B L O W E R M TR .
HEATER BLOWER
CONTROL SW.
\Tr
AIR CONDITIONING R.PO. C70
e YELL.--------------------------
| ia / c
16 YELL.-------------- o-jr
,MED.
|-------- Cl) _
16 LT. BLUE --------*>" RESISTOR

~n
i
BLOWER
CONTROL SW.
t
Cab, Engine, and Chassis WiringHG/HM/JG/JM-7500AMD-3747
CIRCUIT
IDENTIFICATION
A/C COMPRESSOR
a CLUTCH
16 BRN.------------------------
j ON*J
U o ff
if ^ V l
1----- 16 DK. CRN. CZ3- -1 6 BLK.------ 1
r*
i
BLOWER CONTROL
RELAY
1 /6 B L K - 4
/SDK B LU E ----------------------------------------
- 1 6 ORANGE -------------------------------------------
1? }? ,V* J,1i
L -r T--r r- J
--1 j
I
1 16 PURPLE----C l W j f s T ^
-
tS R E D -------------------------------------------------
LEGEND
JUNCTION
SYMBOL
TERM. CAVITY (* 1THRU * 16)
TE RM -XT. STUD-INNER (L.H.)
18 way
m u lt ip le
- ENG. COMRART MENT -OASH PANEL-UPPER R K S O E
-INSTR. PANEL HARN. TO ENG.HARN.-
TERM. X T STUD-OUTER (RH.)
-INSTR.PANEL HARN. TO OR.SW. HARN.-
-INOER WSTR. PANEL AT STEERING COLUMN
<S>
-FUEL TANK SELECTOR SW. WIRE TO FUEL GAUGE TO INSTR. PANEL HARN.
--------- UNDER INSTR. PANEL AT FUEL GA.
CD
ED
\Z7
( 2 )
2 VVAv m u l t i p l e
h d .l
vVAr M U L T .P L E C O N N E C T O R
CONNECTOR -
P a p a r k in g
-STO P
S TAIL L P FRT. EXT. H A R N . T O P E A R S T O P 8 T A IL L R H AR N
-REAR
S T O P 8 T A IL L R H A R N . T 0
CD
SINGLE LINE CONNECTOR -----
-RELATED CIRCUITS
I? POST JCT. BLOCK (*1 THRU *12) -
-INSTR. R6NEL HARN. TO -
-AT
_ r h a r n .-
L.H. F R A M E
S T O P a T A IL L R A S M . ---------
S T O P S TAiL L p r R T . EX t . h ARN.8 F U E L TANK vVIREAXLE SHIFT MTR. SW. CABLE .

AXLE SHIFT MTR. CABLE
k ( WHEN USED)
HEADLAM P
R A IL ( R E A R )
AT S T O P 8 T A IL
-----
ASM.
LR
ASM.
INSIDE C A 8-R K R EA R SlOE
TRAILER CABLE-LINE FU S E --------------------
-CIRCUIT PROTECTOR TOR VOLTM ETER (WHEN USED) 8 AMMETER
AT 18 WAY MULTPLE CONNECTOR
TERM. OR CONNECTOR TERMINATION-,

-RELATED CIRCUITS
SPLICE -------
FU S E ---------FUSE BLOC K-
IN GLOVE BOX COMPARTMENT
CRCUIT B RE AKE R-1

-------- BROKEN LINES
SPECIFIED R.PO. DENOTE WRG. a PARTS OTHER THAN STD.
NOT IN
NOTE- I
CIRCUIT 8 DESIGNATED WIRE AS SUCH APPLY TC A L L
NOTE-2
CIRCUIT 8 DESIGNATED WIRE AS SUCH APPLY TO A L L i AIR i V - 6 D IE S E L MODELS
BUS B A R PA R T OF F U S E
B L O C K - F U S E B lO C K
PART
1A R )
v-6
STaWRG. HARN. ASM'S-
G AS M O D E L S
OF IN S T R .P A N E L
H A R N . ASM.
7-5274
)i--> A/C BLOWER MTR.
ENG GROUND (ALL MODELS)
FRAME
SINGLE-12V. BAT.-FRAME MTD.

( R.PO. T6I GAS MODELS !
i|}----- 0 0 BLK. r-||l
TRANS.
@ j- * 0 0 BLK.||l
FRAME
00 BLK ^\ t
FRAME
DUAL-6V. BAT-FRAME MTD.

( STDrGAS MODELS
DUAL-12V. BAT.-FRAME MTD.

(R.PO. T68 DIESEL MODELS)
SINGLE-12V. BAT.-FRAME MTD

( STD-DIESEL MODELS)
STARTER
STARTER INTERLOCK
HORN
VOLTMETER
AMMETER
R.PO. U3I
GENERATOR
(GMTION-GAS MODELS
CONTROL SWITCH
TEMPERATURE GAUGE
FUEL GAUGE

( GAS MODELS ONLY
DFFERENTIAL LOCK
TELL-TALE
(ALL TANDEM AXLE MODELS)
LIGHTING
MARKER LIGHTS
TRAILER CABLE
R.PO.-U85-U87
STOP LIGHTS
BACK-UP LPS.
HEATER
HEATER BLOWER MTR.
iT
AF CONDITIONING R.PO. C70
---
18 BLK.-------i
iv
a2 )? #
J: j
-r T T T-J
----------------------------------------------- 1
Cab, Engine, and Chassis WiringHE/HJ/JE/JJ-9500MD-3748

1 /6PURPLE----- A/C BLOWER MTR.
CIRCUIT
IDENTIFICATION
Q
TERM. CAVITY ( 'l THRU- 16)
TERM.XT. STUO-INNER (L.H.)
[]
TERM. X T STUD-OUTER (RHj
/a \
-INSTR.PANEL HARN. TO OR. SW. HARN.-
- IWOER INSTR. PANEL AT STEERING COLUMN
<?>
-FUEL TANK SELECTOR SW.W1RE TO FUEL GAUGE TO INSTR. PANEL HARN.-
------------- UNDER INSTR. PANEL AT FUEL GA.
CD
18 WAY MULTIPLE
-ENG.COMPARTMENT-DASH PANEL-UPPER RH SO E
-INSTR. PANEL HARN. TO ENG.HARN.-
- E N G . H A R N . T O H D .L R a PARKING L R H A R N .---------------------n~ 7
C D
WAY M U L T IP L E
AT H E A D L A M P
ASM .
CONNECTOR-
CONNECTOR -
CONNECTOR -
- S T O P a T A IL L R FRT. EXT. H A R N . TO R E A R
S T O P a T A IL LP. H A R N .
- R E A R S T O P 8 T A IL L R H A R N .T O S T O P 8 T A IL L R A S M . ------------
CD
SINGLE LINE CONNECTOR -----------
-RELATED CIRCUITS
( 3
12 P0ST JCT. BLOCK (*l THRU *12)-
-MSTR. PANEL HARN. TO -
LINE FUSE'----------------------
-CIRCUIT PROTECTOR TOR
| STOP a t a i l
FRT. EXT. H AR N. a F U E L T A N K W IR E
AXLE SHIFT MTR. SW. CABLE i
\-( WHEN USED)
L-TRAILER C A BLE------------------ 1
----------------------A IV .M E T E R
(WlN USED) 8
VO LTM ETER
L.H. F R A M E
- AT S T O P
R A IL ( R E A R )
T A IL L R
ASM .
INSOE CAB-RHREAR SIDE

TERM. OR CONNECTOR TERMWATION-RELATED CIRCUITS

SPLICE ---------------------------------FUSE------------------ 1
-FUSE BLOCK-
ORCUIT BREAKER-1
------------ BROKEN LINES 8 SPECIFIED R.PO. DENOTE WRG. 8 PARTS OTHER THAN STD. 8 NOT IN STD.WRG. HARN. ASM'S-
B'JS BAR C'ART OF FUSE BLOCK - FUSE BLOCK PiFiT OF INSTR. PANEL HARN. ASM.
1-5275
- 0 0 BLK.--III
0 0 BLK.
I
|
4-6V. BAT.-FRAME MTD.

( R.PO. T7 6 MI950IA )
( STD.-MH950IA )
,
I
\
\
6 V.
BAT.
4/
'
6 V.
6 V.
hi
bat.
bat.
-I
i______ _________
FRAME
|------- - 0 0 BLK. ----- ||i

I
f 00 BLK.
6V.
BAT.
J f_ L _________________
1
---a~'i'-'3i-K.-1
O O B L K . ^ |i
"
^RAME
DJAL-6V. BAT.-FRAME MTD.

(STD.-MI950IA)
DUAL-12V. BAT.-FRAME MTD.

(R.PO. T68 H I ; Ji/C'/M19500}
( STD.-CH/MH9 5 0 0 )
SINGLE'12V BAT.-FRAME MTD

( ST D.-HI/Jl; Cl/'Ml 9 5 0 0 )
o o - 1|> F R A M E
STARTER
STARTER ASM.
horn
VOLTMETER
AMMETER
R.PO. U3I
GENERATOR
CONTROL SWITCH
TEMPERATURE GAUGE
FUEL GAUGE
DIFFERENTIAL LOCK
TELL-TALE
(A L L TANDEM AXLE MODELS)
LIGHTING
TRAILER LT. CABLE

4 WHEEL TRAILER
R.PO. U88-U93
MARKER LIGHTS
TRAILER CABLE
R.P0.-U85-U87
DIRECTI0NAL-HAZARD 8
STOP LIGHTS
H EA T ED
MIRROR-DUAL HEATED
R.PO. D47
( MI/MH 95010 ONLY )
m ir r o r
E N G IN t B R A K E UNIT
JACAB ENGINE BRAKE

R.PO. K 4 0
( Ml /MH 95010 ONLY )
ENGINE
B R AK E UNIT
-18 LT. CRN. BACK-UP L P S .
BACK-UP LPS.
i4 h / GRN.WHT.CR- TR. -
-16 CRN. WHT. CR. TR.

BACK-UP
L R SW.
f H i>
O - ---- M
2 SPEED AXLE ( WHEN USED !
- 12BLK.(PB8ED )
OK. GRN.------RED S L/E

E E--V E ---- 1&6
-!6
=^ ------ 14 WH T. 2 RED TR.----- (j* )

REAR
X o T *
AX LE
r - ' - T ^ 9'5
^ -1 2 BLK. ^ !
SPEEOO. A DAPTER
BLK.-
BLK-
A XLE SHIFT M TR
')-*
-------------------------- 12 BLK.!SMOOTH} -------
A X L E SH IF T SW.
14 BLUE WHT. CR. TR.
HEATER
HEATER BLOWER MTR

HEATER SLOWER
CONTROL SW.
A /C
$ r
OFF
o,
I //
r_ J p /c
t-0,/
C *-------- 16 Y E L L - -MED- - 16LT. BLUE
-< RESISTOR
Cab, Engine, and Chassis WiringCH/Cl/HI/Jl/MH/MI-9500 MD-3749
BLOWER CONTROL
RELAY
If w ^ i
tO FF
-16 BLK ----- 1
1 16 BLK. ^
XI,,
-r--T T T
j
----I6 D K .B L U E --
CONTROL SW,
j ONJ
SW.
1----- 16 DK CRN. -
r*
BLOWER
COMPRESSOR
8 CLUTCH
16 BRN
^--------* YELL.
1 16 PURPLE------C
16 ORANGE --------
-S P E D -------------
CIRCUIT
ID E N T IF IC A TIO N
|
T E R M . C A V IT Y C
1 T H R U ' 16)
I WAY M ULTIPLE
-ENG. COMPARTMENT-DASH PANEL-UPPER R K SIDE
-iNSTR. P A N EL HARN. TO ENG. HARN.-
TERM -JC T. S T U D - IN N E R ( L H)
[]
TERM . JCT. S T U D - O U T E R (R.H.)
/a\
-IN S TR . PA N EL H ARN. T O D IR SW. HARN.-
<?>
- F U E L TANK S E L E C T O R SW .W IR E TO FU EL GAUGE T O INSTR. PA N EL
<~D
3 WAY M U LT IP LE C O NN ECTO R -
T in
TJJ
CONNECTOR
-STOP a
CT1
CONNECTOR-
- R E A R S T O P a T A IL
C O NN E C TO R
WAY M U LT IP LE C O N N E C T O R
-E N G . H A R N .T O
C =l
H l'j.L P 8
- IN O ER NSTR. PANEL AT STEERING C O L U M N
--------- UNDER INSTR. PANEL AT FUEL GA.
HARN.
AT H E A D L A M P ASM .
P A R K IN G L R H A R N . ---------------------------
CONNECTOR-
SING LE LIN E C O NN ECTO R -------
T A IL L R F R T . EXT. H A R N . T O R E A R
Lf? H A R N . TO
L.H. F R A M E
S T O P 8 T A IL L R H A R N .
-AT
S T O P a T A IL L R A S M . --------------
STOP
R A IL
( REAR )
T A IL L R
ASM.
- R E L A T E D CIRCUITS
I S T O P S TAIL L R FRT. EXT. H A R N . B F U E L
TAN K
W IR E -
A X L E S H IF T M TR . SW. C A B L E i
( 3
12 POST JCT. BLOCK (1 THRU '12) -
-INSTR. PANEL HARN. TO
<^0>
LINE FUSE -----------------
-CIRCUIT PROTECTOR FOR A M M E T E R
AXLE S H IF T MTR. C A B L E
[ ( WHEN U S E D )
1 TRAILER CABLE ------------ 1
--------------(W H E N USED) 8 V O L T M E T E R
INSIDE CAB-RHREAR SIDE
AT 18 WAY MULTIPLE CONNECTOR
TERM. OR CONNECTOR TERMINATION

-RELATED CIRCUTS
SPLICE --------------------------
FU S E ---------FUSE BLOC K^
-------- BROKEN LINES a SPECIFIED R.PO. DENOTE WRG. a PARTS OTHER THAN S T O .a NOT IN STD. WRG. HARN. ASM'S.
CRCUIT BREAKER -
BUS BAR PART OF FUSE BLOC K-FU SE BLOCK PART OF INSTR. PANEL HARN. ASM.
T-5276
\
/
BLOWER MTR.
*0 0 BLK. '
TRANS. l||i
GRD.-ENGINE
FRAME
l|l
S+ 00 BLK--\fl
FRA M E
DUAL* 12V. BAT-FRAME MTD.

R.PO. T68 (HJ/JJ75000 ONLY
dash
iff- /a b l k t ^ j o
b lk -
ENG.
SINGLE-I2V. BAT.-FRAME MTD.-STD.
'0 0 -||i|l FRAME
STARTER
STARTER ASM.
STARTER INTERLOCK
75 0 0 0 ONLY
H J /J J
STARTER INTERLOCK
HV/JV750 00 ONLY
HORN
VOLTMETER
AMMETER
GENERATOR
CONTROL SWITCH
TEMPERATURE AUGE
FUEL GAUGE
ENGINE ALARM RP0.X54
DFFERENTIAL LOCK
TELL-TALE
LIGHTING
MARKER LIGHTS
TRAILER CABLE
R.P0.-U85-U87
STOP LIGHTS
2 SPD W /S WIPER
MTR.0i WASHER ASM.
2 SPD. W/S WIPER
a WASHER
18 LT. GRN.
BACK-UP LPS.
-16 LT. GRN.------ { 13]-----16 BLK.--------- 0 = ^ 0

16BLK.----- fi^ l--- IS LT. GRN-
BACK-UP LPS.
B A C K -U P
LP S .
BACK-UP
- 18 BL K . ------- @ - S i
L.H.
L R SW.
r h i.
------ 14 PtNKLO.
AXLE
axle
s h if t
SPEEDO. ADAPTER
RED SLEEVE
REAR
e BLKj ro b ed J ro > o j T n n r ^ - |;
->4 oK .sm .
12 BLKJ SMOOTH)-
t4 BLK.
AXLE shft mtr

J -
sw.
HEATER
H TR .
ACC.
A/C COMPRESSOR
a CLUTCH
r~~
16 YELL.---------------------------- <31 H i
.
II K>A/C SW.
16 YELL.--------- i--------------------- ^
onJ
- - 16 LT BLUE------- -o~ RESISTOR
Cab, Engine, and Chassis WiringHJ/HV/JJ/JV-7500MD-3750

BLOWER c o n t r o l
relay
jIfif*|k
r*
*
h i
U o ff
----- 16 DK GRN.
BLOWER
CONTROL SW.
->
I6DK BLUE ----
1
16 B LK - ->
I 2 >? , v J; i
L-T--T T T-J
__l
I
|
e R E D ---------
LEGEND
[~]
TERM. CAVITY (" I T H R U '16)
TERM.JCT. STUD-INNER (L.H.)
[]
TERM JCT. STUD-OUTER (R.H.)
18 WAY MULTIPLE
- ENG. COMPARTMENT- DASH PANEL-UPPER R H SIDE
INSTR. PANEL HARN. TO ENG. HARN.-
-INSTR.PANEL HARN. TO DIR. SW. HARN. -
- IMOER INSTR. PANEL AT STEERING COLUMN
<2^
2 WAY MULTIPLE CONNFCTOR
---------UNDER INSTR. PANEL AT FUEL GA.
r r >
U J
VJ
4 WAY MULTIPLE
(T~ i
- R E A R S T O P 8 T A IL L R H A R N . TO S T O P S T A IL L R A S M . -------------
C=J
SINGLE LINE CONNECTOR ----- -
-RELATED CIRCUITS
( 3
12 POST JCT. BLOCK (*1 THRU *12) -
LINE FU S E --------------------
-CIRCUIT PROTECTOR TOR A M M E T E R (WHEN USED) 8 V O L T M E T E R
-E N G . H A R N . TO HD.l R 8 PA R K IN G L R H A R N . ----------------------------
CONNECTOR-
STOP a TAIL L R FRT. EXT. H A R N . TO R E A R
STOP
8 T A IL L R
HARN.
STOP 8 TAIL L R FRT. EXT. HARN. 8 Fl ; . TAN

AXLE SHIFT MTR.SW. C A B LE |
H W H E N USED)
I TRAILER CABLE -------- ---- 1
-------
-AT H E A D L A M P ASM .
L.H. F R A M E R A IL
AT S T O P 8
{ REAR )
T A IL L R ASM .
INSIDE C AB-RKREAR SIDE
TERM. OR CONNECTOR TERMINATION

-RELATED CIRCUITS
SPLICE --------------------------
FUSE -------FUSE BLOCK-
CRCUIT BREAKER-
--
BROKEN LINES 8 SPECIFIED R.PO. DENOTE WRG. 8 PARTS OTHER THAN STD. 8 NOT IN STD. WRG. HARN. ASM'S.
BUS BAR PART OF FUSE BLOCK-FUSE BLOCK PA:;fT OF INSTR. PANEL HARN. ASM.
1-5277
'
)>-> A/C BLOWER MTR.
- 16 ORANGE - -
CIRCUIT
IDENTIFICATION
HEATER BLOWER MTR
-CZ)
HEATER BLOWER
CONTROL SW.
GRD.-CAB-ALL MODELS
DASH
GRD.-ENGINE
T R A N S . i|[
i||----- 10 BLK.------- ||i
||i
ENGINE
FRA M E
r'OO
C A B L E -S T D . ON A L L D IE S E L M O D E LS
L 2 B L K .C A B LE - R .P O . ON A L L G AS M O D E L S j
M T D .B A T T E R IE S
DUAL-6V BAT-FRAME MTD.

R.PO. T66 GAS MODELS

( GAS MODELS-STD.)
STARTER
STARTER ASM.
STARTER INTERLOCK
( DIESEL MODELS ONLY)
HORN
VOLTMETER-R.PO. UJO
AMMETER
W IRE W ITH RED S L E E V E
GENERATOR
IGNITION-GAS MODELS
CONTROL SWITCH
TEMPERATURE GAUGE
FUEL GAUGE

(GAS MODELS ONLY)
DIFFERENTIAL LOCK
TELL -TALE
LIGHTING
MARKER LIGHTS
TRAILER CABLE
R.PO.-U85-U87
DIRECTIONAL-HAZARD B
STOP LIGHTS
2 SPD. W/S WIPER

a WASHER
BACK-UP LPS.
BACK-UP LPS.
2 SPEED AXLE ( WHEN USED
HEATER
HEATER BLOWER MTR.
\?> ]
]? )? S* Jj 1
-T--T--T T,
-I
I
I
> /6PURPLe--- C 3 - ^ T C T ^ S
LEGEND
CIRCUIT
IDENTIFICATION
Zi7
2 WAY M U LT IP LE
C O NNECTOR
- A X L E SH IFT
SW. C A B L E
TO A X LE
SH IFT M T R . C A B L E
d )
C O NN E C TO R
- A X L E SH IFT SW. F E E D WRG. HARN TO AXLE S H IF T
TERM. CAVITY (* I THRU 16)
INSIDE C AB-R.H . R E A R SIDE
Cab, Engine, and Chassis WiringHG/HM /JG/JM -7500VMD-3776
TERM -XT. STUD-INNER (LJH.)
18 WAY MULTIPLE
SW. C A B L E
-ENG. CCMRARTMENT-DASH PANEL-UPPER R H SIDE
INSTR. PANEL HARN. TO ENG. HARN-
T E R M .'X T STUO-OUTER (RR)_
8 W lf MULTIPLE CONNECTOR
-UNDER INSTR.PANEL AT STEERUG COLUMN
<E>
-FUEL TANK SELECTOR SW.WIRE TO FUEL GAUGE TO INSTR. PANEL HARN.-
---- ----- UNDER INSTR, PANEL AT FUEL GA.
CD
eh
2 WAY M U LT IP LE
\Z7
4 WAY M U L T IP L E C O N N E C T O R -
- S T O P 8 T A IL L P FRT. E X T. H AR N. TO R E A R
QD
CONNECTOR-
-REAR
(U
CONNECTOR -
EZ
2 WAY M U LT IP LE
CONNECTOR -
AT H E A D L A M P
-ENG . H A R N . T O HD.LR S PARKING. L R H A R N .
SINGLE LINE
CONNECTOR----
LINE FUSE-------------------
STOP
S T O P 8 T A IL L R H A R N . T O S T O P 8 T A IL
IN S T R . P A N E L H A R N .T O
C3
ASM .
CONNECTOR-
8 T A IL
LR H A R N -
L R A S M . ------------
S T O P 6 T A IL L R FRT. EXT. H A R N .-
-L.H. F R A M E R A IL ( R E A R )
AT S T O P
T A IL L R
ASM .
INS ID E C A B - R .H . R E A R
SIDE
- R E L A T E D C IR C U IT S
-CIRCUIT PROTECTOR FOR VOLTMETER (WHEN USED) a AMMETER
AT 18 WAY MULTIPLE CONNECTOR
TERM. OR CONNECTOR TERMINATION-RELATED CIRCUITS

SPLICE -----
F U S E --------
-FUSE B L O C K - P A R T OF IN S T R .P A N E L H AR N.A SM .-
ORCUIT BREAKER-
BROKEN LINES
SPECIFIED R.PO. DENOTE WRG.
a PARTS
OTHER THAN S T O .8 NOT IN STQ.WRG. HARN. ASM'S-
NOTE- I
ORCUIT a DESIGNATED WIRE AS SUCH APPLY TO A L L (VAC.) V - 6 G AS M O D E L S
NOTE-2
CIRCUIT a DESIGNATED WIRE AS SUCH APPLY TO A L L (VAC.) V - 6 D IE S E L M O D E L S
T-5278
B-JS BA R PA RT OF FU SE BLOCK - FUSE B LO C K PA RT
OF IN S TR . PA N EL H AR N. ASM.
.
A/ c BLOWER MTR.
l| ----- 10 BLK.
GRD-CAB-ALL MODELS
DASH
GRD*ENGINE-FRAME MTD. BAT
t r a n s . i||------- 2
b l k .----- -||i
fra m e
R.PO.
DUAL-6V BAT-FRAME MTD.

R.PO. T66
SINGLE* 12V. BAT.-FRAME MTD

R.PO. C70
STARTER
STARTER ASM.
HORN
VOLTMETER
AMMETER
GENERATOR
IGNITION-GAS MODELS
CONTROL SWITCH
TEMPERATURE GAUGE
FUEL GAUGE
DUAL FUEL TANK-R.PO. NQ7

( GAS MODELS ONLY )
DIFFERENTIAL LOCK
TELL-TALE
LIGHTING
MARKER LIGHTS
TRAILER CABLE
R.PO.-U85-U87
NOTEr TRL. PLUGS

SHOWN LOOKING AT
OPEN MATNG END
R.H. STOP-TAIL
DIR.Lfi
STOP LIGHTS
LICENSE LP.
L.H. STO P-TA l

wr. lp
2 SPD W/S WIPER

MTR. WASHER ASM.
2 SPD. W/S WIPER

a WASHER
SPD. w/s w ipe r
WASHER SW.
I O
I O fF
16 BLUE WHT. CR. TR.
BLK .-------- @ -T i' R.F
18 LT. GRN. -
BACK-UP LPS.
\ w \ - I 6 GRN. WHT. CR. T R .-
GRN. WHT. CR. TR.-\13 F
BACK-UP LPS.
BACK-UP
& IT. GRN. -
L R SW.
----- S
RED S L E E V E
-14 WHT. 2 RED TR.
L.H.
BLK.( RB8ED ) I
4T-0BLK.-
SPEEDO. ADAPTER
FfEAR
, I AXLE SHFT MTR.
- S B L K .i SMOOTH }-
---------< * > -
AX LE
-@ -5'
A X L E SH IFT SW.
14 B L U E WHT. CR. TR.
HEATER
i
]
Ivo
\
A /C
I , , FF
, ------- 16 YELL.-------------------------------------------- < J ll!
.
\ | / / LO.-'
II W) A/C SW.
-------- 16 YELL.--------------- o -^
|------- Cjl II
0 ^ - 9 '- - 16LT. BLUE----------- RESISTOR
G-------- ---------- j
I--------16 DK. GRN. ~i
o*
BLOWER CONTROL
RELAY
IV * * * I
%-*%
U-OFF
-1 6 BLK.-------- 1
L -/S BLK- ->
I I----------------------------- 16DK. BLUE------I

-------------------------------16 O R M G E ----------
BLOWER
CONTROL SW.
-----
j ON*J
COMPRESSOR
a CLUTCH-
j ----------------------16 BRN.--------------------------------------------------- 1
Cab, Engine, and Chassis WiringHM / JM-8500MD-3777

CIRCUIT
ID EN TIFIC ATIO N
HEATER BLOWER MTR.
HEATER BLOWER
CONTROL SW.
jJi? T
?|
)? v J; i
L-r--Tt-_t-J
J
'--/6PURPLE ----- O ' T C i T ^
------------------- --------------------------------------------------!6 R E D ------------------
JUNCTION
SYMBOL
TERM. CAVITY Cl THRU* 16)
TERM.XT. STUD-INNER (L.H.)
i WAY MULTIPLE
C ONNECTOR
-ENG. COMPARTMENT-DASH PANEL-UPPER RH SIDE
INSTR. PANEL HARN. TO ENG. HARN.-
TERM. JCT. STUD-OUTER (RH.)
UNDER INSTR. PANEL AT STEERING COLUMN
-INSTR.PANEL HARN. TO DIR. SW. HARN.-
<S>
CD
--------------UNOER INSTR. PANEL AT FUEL GA.
-A T H E A D L A M P A SM .
- E N G .H AR N. TO HD.LF? a P A R K IN G L R H A R N . ---
YT\
CONNECTOR -
VT7
CONNECTOR-
-STOP
C2~i
CONNECTOR-
-REAR
S T O P 8 T A IL
L R H A R N . TO STO P 8
CH]
SINGLE LINE CONNECTOR ----------
-RELATED CIRCUITS
{~)
12 POST JCT. BLOCK (*l THRU 1 2 ) -
>
- AT S T O P a
T A IL L P A S M . ---------
STOP a t a i l L P FRT. EXT. H A R N . a F U E L TAN K

AXLE SHFT MTR. SW. CABLE >
^ ( WHEN USED)
-TRAILER CABLE -----CIRCUIT PROTECTOR TOR A M M E T E R (WHEN USED) ft V O L T M E T E R -
LINE FUSE-------------------------------
- L.H . F R A M E R A IL ( R E A R )
T A IL L R FRT. EXT. H A R N . TO R E A R S T O P 8 TAIL L R H A R N
T A IL
LP
AC M .
W IRE
INSOE CAB-RRREAR SlOE

AT IB WAY MULTPLE CONNECTOR
TERM. OR CONNECTOR TERMWATION-RELATED CIRCUITS

SPLICE ----------------------------------------FUSE-----------FUSE BLOCK-
ORCUIT BREAKERBROKEN LINES a SPECIFIED R.PO
D E N O T E WRG.
8 PARTS OTHER THAN STD. 8 NOT IN STD. WRG.HARN. ASM'S.
BUS BAR PART OF FUSE BLOCK-FUSE Bl OCK PART OF INSTR. PANEL HARN. ASM.
T-5279
A/C BLOWER MTR.
-C A B -A L L
DASH
M O D ELS|
G R D .-E N G iN E
l|^- 9 CRD. STRAP j| l
ENGINE
4 CRD. S T R A P - - ||l
FRAME
TRANS. ||[

{ R.RQ 070 V b GAS
SINGLE-12V. BAT-FENDER MTD

( OAO .m o d e , s ONLY
(V-6 DIESEL STD.)

jRD.-F_(MG.(V-6 DiESEL STD.)
STARTER
STARTER ASM.
STARTER INTERLOCK
(DESEL MODELS ONLY)
HORN
VOLTMETER-RPO. UiO
AMMETER
GENERATOR
IGNITION-GAS MODELS
CONTROL SWITCH
RK E. W A R N IN G
BRAKE WARNING T. T.
VAC. MODELS
R.PO. JL4 $ R.PO. JL5
iR K E . W A R N IN G
SW.
LR
TEMPERATURE GAUGE
FUEL GAUGE
LOW VAC. ALARM BUZZER

VAC MODELS
R.PO. JL4 $ R.PO. JL5
ENGINE ALARM R.PO.X54

AIR MODELS
LOW VAC. ALARM BUZZER

DIESEL MODELS-STD.

STD.AIR MODELS
LIGHTING
MARKER LIGHTS
TRAILER CABLE
R.P0.-U85-U87
AIR MODELS
DIRECT IONAL- HA Z ARD

STOP LIGHTS
2 SPD. W/S WIPER

a WASHER
2 SPEED AXLE
R.PO.
RADIO-R.PO. U60
BACK-UP LPS.
HEATER
HEATER BLOWER MTR.
Cab, Engine, and Chassis W iring-EM/ES-4S00V ; EG/EM-5500-6500A/V; ES-5500V-MD-3800
^ "c+1
J,1j'
|_!2j?
L-T--T [ T-J
--J
CIRCUIT
IDENTIFICATION
1 16PURPLE--- C 3 - - 'T C T '- S
A/C BLOWER MTR.
JUNCTION
SYMBOL
[8]
CONNECTOR
C 5 I5
C O NN ECTO R -
C O
3 WAY M U LT IP LE
CONNECTOR-
-IN STR . P A N EL
3 WAY M U LT IP LE
CONNECTOR -
-INSTR. PANEL HARN.
[ X 7'
3 WAY M U LT IP LE
CONNECTOR-
2 WAY M U LT IP LE
C O NN ECTO R -
ENG. A L A R M H AR N. TO \
0T7
3 WAY M U LT IP LE
C ONN ECTOR -
-IN STR . P A N E L H A R N .T O T R A 'L E R E x T H a RN.
C3D
CONNECTOR -
2 WAY M U LT IP LE
C O NN ECTO R
/g\
8 WAY M U LT IP LE
CONNECTOR-
IN S TR . PA N E L H A R N .T O DIR. SW. H A R N .-
ZjD
2 w/w
CONNECTOR -
AXLE
-IN STR . PANEL HARN. TO ENG. HARN.
HARN. TO ENG. H A R N . ( GAS M O D E L S )

- INSIDE CAB-UNDER INSTR. PANEL-UPPER R.H. SIDE
TO S T A R T E R IN T E R LO C K H A R N . ( D IE S E L M O D E LS )
WAY M U LT IP LE
-ENG. H A R N .T O H D.LR 8
071
M U LT IP LE
2 WAY M U LT IP LE
C O N N E C T O R ----------
SHIFT SW. C ABLE
i_OW OIL PR ESS. SW. W IRE ---------
-INSIDE CAB-IN INSTR. PANEL REIN FO R CE M E NT-N EA R FUSE PA N EL
-AT H E A D L A M P ASM.
PARKING L R HARN.-
TO A X L E
- UNDER
INSTR. PA N E L AT STEERING COLUMN
SH IFT MOTOR C A B LE
- A X L E SH IFT SW. FEE D WRG. H AR N. TO A X L E
S H IF T SW. C ABLE
-INSID E CAB-R.H. R E A R SIDE
6 PO ST JU N CTIO N
BLOCK ( * l T H R U * 6 ) -
nn
2 WAY
n r?
2 WAY M U LT IP LE
C ONNECTOR ---------- [
CD
4 WAY M U LT IP LE
C O N N E C T O R ----------
CUD
2 WAY M U LT IP LE C O N N E C T O R --------
M U LT IP LE
C O N N E C T O R ----------
- T R A IL E R EXT. C A B L E
A SM . TO T R A IL E R
C A B LE
ASM.
- INSTR. PANEL HARN. TO STOP
TAIL L R FRT. EXT. H A R N .-
-IN STR. PANEL H A R N .
[o]
JU N CTIO N BLOCK (F U S IB L E
C ZI
SINGLE LINE C ONNECTOR
- T R A IL E R EXT. C A B L E - STOP
-R E A R
t a il
STOP 8 TAIL L R H A R N .T O
- L.H. FRA M E R A IL ( RE A R )
TAIL LR H A R N .-
- AT STO P 8 T AIL
STOP 8 TAIL L R A S M .------------
L R ASM.
LIN K )
-R E LATED
O
L R FRT. EXT. H AR N. TO RE A R STOP
CIRCUITS
T E R M . OR CONNECTOR T E R M IN A T IO N
S P LIC E
- CIRCUIT
L IN E F U SE-
PR O TE C T O R FOR V O L T M E T E R ( WHEN U SED ) 8 A M M E T E R -
- AT
WAY M U LTIP LE
-FUSE B L O C K - P A R T OF IN S TR . PA N E L H ARN. A S M .
CIRCUIT B R E A K E R -----------
------ b r o k e n l i n e s
*-
s p e c if ie d
r .p o
. denote
w rg.
parts
other
th an
std
not
BUS BAR PART OF FUSE BLOCK-FUSE BLOCK PART OF INSTR. PANEL HARN. ASM.
in
std
. w r g . h a r n . a s m s .
T-6358
mOO BLK . *||> F R A M E I 1 1*00 BLK.

6V-
BAT.
0AT' /
4 - 6 V. BAT. F R A M E ' MTD.
~ ^ m * 0 0 BLK.^ y
DUAL-I2V. BAT-FRAME MTD.

R.PO. T 6 8
(iT A
KTl)
6V. \ j W
_BAJ.
FRAME
'if -
'OO BL K.'
'OO- ||i FRAME
STARTER
STARTER ASM.
- /<? BLK.
STARTER INTERLOCK
18 BLK.-
MAGNETIC
STARTER SW.
STARTER
INTERLOCK RELAY
HORN
L r:
Eoi-
HORN
BUTTON
- [ 7 ] ----------- 18 BLK.----------- ----------------- 8 BLK.------------
VOLTMETER
VOLTM ETER <6
AMMETER
R.PO. U3I
TRANSGTOR1ZEO
VOLTAGE REGULATOR ( S T D .)
GENERATOR
6 2 AMf? (STD.)
AM M ETER
v t? )
[Tel /8 BLK. WHT. TR.
WIRE WITH RED SLEEVE -
16 B LK -( FUSIBLE LIN K )
10 BLK*
ii . 1 1 14 RED -
GENERATOR
--------- 18 B L K .
{ I ] ---------
A mmm 10 BL K.
B
18 BLK.
12 BLK.
0 12 BLK.E -
2 4 BRN. WHT. STR ( 10.01 10 OHM.)
12 B L K .
12 BL K.
- 2 4 BRN. WHT. STR. (ZOO : 10 OHM.)-
N O T E - L E T T E R S "A THRU E " FOR CIRCUIT CONTINUITY ONLY.
|.
FUEL
SH U TO FF
SOLENOID
IGNITION-GAS MODELS
CONTROL SWITCH
TEMPERATURE GAUGE
FUEL GAUGE
ENGINE ALARM R.P0.X54-
DIFFERENTIAL LOCK
TELL-TALE
( A L L TANDEM AXLE MODELS
LIGHTING
MARKER LIGHTS
TRAILER CABLE
R.PO.-U85-U87
DIRECTIONAL-HAZARD &
STOP LIGHTS
BACK-UP LPS.
BACK-UP LPS.
L.H.
S O L. A IR
2 SPEED AXLE
AIR OPERATED
VALVE
SPEEDO. A D A P T ER
3 SPEED A X LE
AIR OPERATED
(TANDEM A X LE MODELS)
S O L . AIR VALUE
(TANDEM A XLE )
HEATER
HEATER BLOWER MTR.
AR CONDITIONING R.PO. C70
-J
CIRCUIT
IDENTIFICATION
I 16 PURPLE----- O - ' T f c T ' - S
p > A/C BLOWER MTR.
LEGEND
TERM. CAVITY (* I THRU" 16)
[3
TERM-JOT. STUD-INNER (L.H.)
c r
18 WAY MULTPLE
INSTR. PANEL HARN. TO ENG. HARN,-
-ENG.COMPARTMENT-DASH PANEL-UPPER RHSIOE
3
Q
TERM. X T STUD-OUTER (R H [
3*
/e\
- INDER HSTR. PANEL AT STEERING COLUMN
<?>
-FUEL TANK SELECTOR SW. WfiE TO FUEL GAUGE TO NSTR. PANEL HARN.
--------------UNDER INSTR. PANEL AT FUEL GA.
n n
3 WAY MULTIPLE CONNECTOR------
2 WAY M U LTIP LE C O N N EC T O R -
\~T7
4 WAY M U LTIP LE
CD
<Q
3
Q .
-E N G .H A R N .T O HD.LF? a PARKING L R HARN. -
AT H E A D LA M P ASM.
55
<
<
= ?
-STOP S TAIL LR FRT. EXT. H A R N .T O RE AR STOP 8 TAIL LP. HARN.
L.H. FRA M E
2 WAY M U LTIP LE C O N N EC TO R-
- R E A R STOP a TAIL L R HARN .TO STOP 8 TAIL LR A S M .-----------
- A T STOP 8 TA IL L R ASM.
CU
SMGLE LINE CONNECTOR -------
-RELATED CIRCUITS
Q )
12 POST JCT. BLOCK (*1 THRU *12) -
-NSTR. PAKEL HARN. TO
LINE FUSE'-------------------------------
-CIRCUIT PROTECTOR FOR AM M ET ER (WHEN USED) 8 VOLTM ETER
C O N N EC T O R -
R A IL ( R E A R )
STOP a TAIL LP FRT. EXT. HARN. 8 FUEL TANK WIRE

0
**
51
o
tn
AXLE SHIFT C A B LE
T R A IL E R CABLE
INSIDE CA8-RHREAR SOE

TERM. OR CONNECTOR TERMINATION-,

-RELATED QRCUTS
SPLICE ----------
11
DD
FUSE------------IN GLOVE BOX C0MR4RTMENT
-FUSE BLOCK ORCUIT BREAKER-1
1
i
O l Lh
00 O'
hO
r-
K )
&.
------------ BROKEN LINES 8 SPECFEO R.PO. DENOTE WRG. 6 PARTS OTHER THAN STD. 8 NOT IN STD. WRG. HARN. ASM'S.
*
BUS BA R PA R T OF F U S E BLO CK - FU SE B L O C K P A R T
OF IN S T R . PA N EL H A R N .
ASM.
T-6359
LEGEND
SYMBOL
JUNCTION
5 PO ST JC T -
8 WAY CON N. IN S T R , P N L. HARN. TO DIR.& HAZ. WARN. SW. HARN. ASM . U N D ER IN STR. P N L. AT S T E E R IN G CO L.
CZ)
2 WAY CONN.
d>
FUNCTION
LOCATION
PLU G TO B A T T E R Y BOX H E A T E R
1im c t d
R A D IA TO R S H R O U D -L .H .S ID E
u a dm t -r\ i i_i u r ni n o c u f
omi
2 WAY CONN. S T O P -T A IL& B/U L P R EA R WRG. HARN. ASM. TO S T O P - T A IL LR ASM.-
AT H E A D LA M P ASM,
-AT S T O P -T A IL LA M P S
H 5
3 WAY C O N N .----------------- -RAD IO C A B L E ASM. TO IN S T R . P N L. HARN. ------------- AT RADIO IN C O N S O L E COMPT,
Z37
a w ay
3 WAY C O N N .------IN ST R . P N L.H A RN . TO CAB M K R .& DOME L P WRG. H A R N .A S M . UNDER IN S T R .P N L . L.H .S ID E

rn w N
c w r u a q w t o JS T O P -T A IL &
4 WAY CONN. ENG. HARN. T O - j ^ p , ^ , ^
liT O P - T A IL & B/U
4 WAY CONN.
[S T O P -T A IL & B/U
S IN G L E L IN E C O N N .------------------------------
ea
S IN G L E L IN E CONN. (D H / F H 9 5 0 2 ON LY)-
T E R M IN A L OR CONN. T E R M IN A T IO N ------
S P L I C E -------------------------------------------------
q _/~ b L IN E
*
B/U LR FR T. WRG. HARN.ASM. (D I/D H 9 5 0 2 ONLyYI

. u C D A liC DAM
m LR r e a r WRG. HARN. A S M .(F l/F H 9 5 0 2 O N L Y ) p L H ' FR A M E RA'L
L R F R T WRG. HARN. ASM. TO
-L.H .FR A M E R A IL
LR R E A R WRG. HARN. ASM. (D I/D H 9502 ONLY)
R E L A T E D C IR C U IT S
N O T E - A L L W IRES TO BE BLK
F U S E -------------------------------------------
BUS B A R ---------------C IB C U IT
FEED
b r ea k er
FO R M U L T IP L E C IR C U IT B R E A K E R S E L E C T . E Q U IP P N L t C O N S O L E COMPT.
U N LESS OTHERW ISE SPECI
ELECT. EQUIP. P N L t C O N S O L E COMPT.
FIED & BROKEN LINES DENOTE

W R G & PARTS O TH ER THAN
32 WAY CONN. (A S THRU JX)
o
GD
6 POST JCT (*l THRU *6 )
2 WAY CONN.----- IN STR . PN L.H A RN . TO EX H . PYRO, GA. S E L E C T
(51
(3)
---- INSTR. PNL. HARN. TO ENG. HARN.-RH. SIDE-UNDER DASH

INSTR. PNL HARN. TO TRAILER CABLE ASM:---- --- ELECT. EQUIP PNL. CONSOLE COMPT.
2 WAY CONN.-
STD & NOT IN S TD WIRING.
IN S T R . P N L.H A RN . TO CAB WINDOW L I F T W IR E ASM.----------- R .H .S ID E -U N D ER DASH
2 WAY CONN. ----------------IN STR. PN L. HARN. TO C L U T C H

4 WAY CON N -------------------ENG HARN TO GEN
SW .& W IRE ASM .------------------- AT EXH. PYRO. GA.
SW, W IR E A SM .---------;------------
LH. S ID E -U N D E R DASH
HARN ASM -------------------------------------------------- AT S T A R T ER ASM
3J WAY
WAT CONN
CUNN
INST
m S T PNL
PNL HARN
HAHN TO
TO COOLANT
COOLANT LOSS
LOSS INDIC
INDIC HARN.
HARN. ASM
ASM ------------ ELEC EQUIP'T PNL-CONSOLE COMP'l
SPARES-EN G . H ARN .-----[gv]---- */6 -
BAT. BOX
HEATERS
-jS PA RlT]- {fvJ--- * 6 ----{SPARE Z\-
J g U ] ---* 6 ---- [SPARE3 |-
-------- 7 ^ 7 ------- 12 w h t ------________ / 2 B , K ___________
V,
'
^
^
RECEPTACLE
*OO^IFRAME
FRA M E
r O O - ^ l ' FRAM E
-*0 0 -# F R A M E
[fu]--- *
----
14
bat
box
HTR.
j (U P p E R)
.REV. B j
jc^vwA~1 b a t. BOX H TR
|. CIR. BRKE. MTG. BRKT.
I ' FRAME CAB GROUND
BATTERIES
H l' E N G , GRD.
STARTER
FR A M E
AMMETER
STARTER
ASM.
GENERATOR
STARTER
INTERLOCK
MASTER
CIRCUIT
BREAKER
HORN
- 1 8 ----
RADIO
-I6 B R N B LK TR-
o CD O ! I---- 1 8B L U E 533--- 18 B L U E -- (D 18DK B LU E ~ [_
-35 IS B RN B L K TR -^xJ' b---- 18 BRN B LK T R ----
RADIO S P K R .
RAD IO
PYRO. S E N D E R
3 - - r - o - - ie - a $6 f ii} te w h t r e d t r ------ 1<> f 07C
16 W HT BLK CR TR
S-
o PYRO. S E N D E R (R.H.) ,___ ,

-o @
GAUGES
16 WHT // RED T R
f.
16CRN B LK TR-
, W ATER TEM R
SEN D ER
S E L E C T . SW. -to- -1
- ro
t oAK - T 2
W ATER T E M P GA.
p PYRO . S E N D E R (L.H.)
p * - j o- )6 Q */S ---- |BS}:i-
j- c O I L P R E S S ,
i 5 SEN DER
O IL P R E S S . GA.
16 W HT GRN TR
i R R
KJ3
DY 16-
16 W HT // RED TR(o J o )!6 B LU E
PYRO. GA.
\/\Ar F U E L GA.
* ! TANK U N IT
16 WHT // RED T R ---(o\ ^-/6 BRN WHT CR T R (dzJ
^
16 WHT RED TR
O IL T E M P S E N D E R
-~/6 */6 --|It|-16RED B LK TR\o f
^
FU ELG A .
i 6 WHT // RED TR
ENG. O IL TEM P GA.
*1 C. B.
r/OW HT RED CR
-16 WHT // RED TR
Azj-- 16 YELL //B LU E TR
..*10 RED
18RED W HT TR -----
CONTROL SW.
RUN
BAT..|GN, ACC.
O F F L O C K E D OPEN
ACCESSO RY
BAT. $ A C C .
ENG. ALARM
16 YELL // B LU E TR
LO. O IL I T .
C IR C U IT
P O S IT IO N
16B LK C R N TR
1 /8 RED WHT T R --- ---------16 B LK CRN T R ---LO. AIR T.T.
SW'ii^ X 6 - *6
LO AIR
18 RED WHT TR
LO AIR S W / l r ^ I ^
------ \m\-!6BLK GRN TR
I 6 GRN WHT TR
LO. W A TER T.T,
HOT ENG.SW.'!; c ^ - D * 6 ------[ey|- 1 6 CRN WHT TR
/6 W H T// RED T R
D IF F L O C K T.T.
ACCESSORY
FEED RELAY
TACHOGRAPHS
D IF E L O C K SW.
18 R ED WHT T R - ^ j -- 16 GRN WHT CR TR
-16 RED W HT TRi.
TACH O GRAPH S
(M.RH.)
(R R M .)
^
ACC. F E E D RLY.
'-0 IG N .I
r /0 RED WHT CR TR 1
LOW COOLANT
INDICATOR
^_______-/ 8 ____
d\
J-o LT.
^------- !8
r
^ C .B .
LOW C O O L, P R O B C
2 SPD. AXLE
A IR P R E S S . SW.
3
O--------
S O L . A IR V A LV E
(2 S P E E D A X L E )
3 SPD. A XLE
STARTER SW.
S O L. A IR V A LV E
(3 S P E E D A X L E )
8 C.B.
30AT
S T A R T SW.
S T A R T SW. (AUX)
- 1 6 WHT H RED TR [ez| 16
Z7^ q
----16 WHT //R E D TR-
-16 M ARO O N -
(BY
-16-
A A IR
BACKUP
L R SW.
BACKUP LP
-16L T GRN~
O FF
1
C O N D .
h*ON
-
rf-----16 B R N
I
JACOBS
ENGINE BRAKE
'^ /6 B R N B LK T
8A .
o-
14 RED WHT TR
WINDOW
x Y
30A
i
S P E E D O .I
r@ -
A M M ETER
EXH. PYROM ETER
18GRAY-------j!' V O L T M E T E R
--- 18 GRAY----- ' / j
18 CRAY ------ {:
--- 18 G RAY----- /j
/8 GRAY ---- r - ^
IGGRN^ T T ^ - ^ K
5
14 RED
L.H, H EA D LA M P
O IL P R E S S . GA.
AI R GA.
11 /6
18GRAY-------j;. F U E L GA.
;; . _ 0 ---- 18 G R A Y ------- ^# 7 C . a
LIGHTING
WINDOW
L IF T (R.H.)
M G R A Y - fo - ^ - ii', TACHO.
J8 GRAY
L -{nry----- i g q r a y --------
B R A K E AIR GA.
ENG. B R A K E U N IT
~ 14BLUE WHT TR ( U ------ 14B LU E WHT TR------- CAB

-14 B R N W HT T R ( 2]----14B R N WHT TR
r ~ ~ jp
-14 POWERED
*.||
WINDOW SW. |--------- j
O IL T E M P GA, -4^)--- 18 G RAY

AIR R E S T R . GA.
--------------1
>6 GRN
D O W N 1-
18 GRAY
- p 4 ^ W ; ,j E N G .B R A K E U N IT
Z l
r-OAi
MICRO.
B U F F E R SW.
-------------I I
-18 GRAY
-18 GRAY
-18GRAY
TT
FR T . B LO W ER
*
COMMON 61
Dl^ ^
J / ' H I'
-16----ia = ^
^
---------- 16 GRN-
N O TE-SW . CO N TA C T SHOWN IN
C L O S E D P O SITIO N W ITH C LU T C H
P E D A L IN NORMAL P O SIT IO N .
IIC.B.
POWERED
------- 14 O RAN G E
-16BLUE WHT CR TR
C LU T C H SW.
-(2 )-*/6 ---- Ucr^Q 7 6 ----(2) ^|B Z| 16
16 B LU E WHT CR T R -
R EA R BLO W ER
R E S IS T O R
-------14 O R A N G E ---
ENG. B R A K E SW.
IO C .B .
I60RANGE-
14 Y E L L
14 B LU E W HT CR TR-
MED
,, A/C C O M P R E S S O R
1 '' $ C LU T C H A
------------ jc s )*6
14 YELL-
UoA/C SW, A
,L0
- 1 4 B R N ------------- jH E A T E R BLO W ER|
C O N T R O L SW. !
HEATER
16 G R N -
f r ) -------|l' B A CK U P L P
- W -- I6 L T C R N -
'--- 1 8G RAY---- W A TER T E M P GA.

\ ~I6GRAY
j - 14 BLU E WHT CR TR
18GRN WHT CR T R @ H : HI. BEAM T T.

r- 1 4 CRN WHT CR T R ---------------------
Cab, Engine, and Chassis WiringDH/DI/FH/FI-9502MD-5281
os:- 9 14 CRN WHT CR TR
I4 G R N WHT CR TR -^*\ -*4--- (2 ) -----R .H .H EA D LA M P
- I4 B R N WHT CR TR -----(3D--- TAN
16B RN WHT CR T R ---iCYl---16I
MARKER LAMPS
o S k
L I LIG
IRHT
9.W------- 1
H T SW.
VOLTMETER
DOME L P
-CF-^O-k
C A B FRT. M KR. L P S .
16 MAROON
MKR.
!' S L E E P E R
DOME L P
[ ~
r ^ x s l
MOM.O 0 N ;
TRAILER CABLES
DIRECTIONAL-HAZARD
t STOP LAMPS
----------
L __ 2=rL___________
I.C.C. MKR. L P S .
B L K
BRNRED :
) 16 BLUE ( 3 ) 16 Gfl/V-jwx|---- ,
HAZARD [
a ol
WARNING [ o 3
!
P O S IT IO N |
[p~s] / 4
R.H.FRT. D IR .& P K .L P
AIR
ST O P SW.
r'o T l
i
R .H .T U R N I
fcg !
SO P O SITIO N 1 ^ 3 o j
I---- f - 16 MAROON --------------M 16
'
I8BLUE WHT CR T R
Q
L. H. D IR .T .T .
/6 MAROON ----------- CD---------TR
16 G R N ----- 0
DIR.& HAZARD
WARNING SW.
(NEUT. POSITION)
12B LU E- S P A R E
12BLK-I.C.C.
LPS.
r r -=~1
,
'BLK-I.C.C. MKR. L
P
- I2 BBR
R NN--TA
T A IL LPS .
.---------SEM I. T R L .P
L U I.G T R
SEM
7 WIRR E
12RED -STO P LPS.---- r '
12GRN-R.H. DIR. LPS.
o, '
R.PO. U 8 7
12 YELL- L.H. D IR. LP S .---- >l|---- 10 G R A Y ---------T R A IL E R C A B L E S
'II----14 W H T ------------- 1
- I4 B L K - IC .C . MKR. L P S .^ ^ - 1
14 B R N - T A IL LPS.~-------SEM I. T R L .P L U G
14 RED -STO P L P S ------- [-1
6 W IR E
~ /4 GRN-R. H. D IR. L P --- R-P 0 -U 8 5
14 YELL - L. H. DIR. L P .----
R.H. D IR .T .T .
-16 D K G R N - C D IB-
3 2 ------ 16 D K
G R N -----W
- I6 B R N - S & - I6 B R N E ?
% /Y
R.H. S T O P - T A IL
' & DIR. L P
^ < Z > - I8 B LK WHT S T R
L.H.FRT DIR.& PK.LP

-WHT-
lisl------- *6 --------
16 BRN -
16 B R N ---( T )
I 6 BRN16
L.H.
16-
Hi' L I C E N S E L R
-Ij-G R O S T R A P
^ -< JD -/8B LK
WHT S T R
Y E L L ---- W ----- 16 Y E L L ---CZ>-foL.H . TU RN L - q
o]
P O SITIO N J _
L .H .S T O P -T A IL
*' & D IR. L R
663654
T-6360
LEGEND
SYMBOL
JUNCTION
FUNCTION
3 WAY CONN.--INSTR. PNL. HARN. TO COOLANT LOSS INDIC.HARN.
LOCATION
-AT CONTROL SW. IN CONSOLE COMP'T.
5 POST JCT. - -------- PLUG TO BATTERY BOX H E A T E R ------
----
RADIATOR SHROUD-L.H. SIDE
8 WAY CONN. I NSTR. PNL. HARN. TO DIR. & HAZ. WARN, SW. HARN. ASM. -UNDER INSTR. PNL. AT STEERING COL.
fENG. HARN. TO R.H. HEADLAMP ASM.
)
2 WAY CONN.
-----------------AT HEAD LAM P ASM.
1 INSTR, PNL. HARN. TO L.H. HEADLAMP ASM.J
2 WAY CONN.-STOP-TAIL & B/U LP REAR WRG. HARN. ASM. TO STOP-TAIL LP ASM.---- AT STOP-TAIL LAM PS
3 WAY CON N .------------ RADIO CABLE ASM. TO INSTR. PNL. HARN.---------- AT RADIO IN CONSOLE CO MPT.
3 WAY CONN. I NSTR. PNL. HARN. TO CAB MKR. & DOME LP WRG. HARN ASM UNDER INSTR. PNL.-L.H.SIDE
/i w av r n u M - r M r u a d m r n JSTOP-TAIL & B/U LP FRT. WRG. HARN, ASM. (DC/DN9502 ONLY'].

4 WAY CONN. ENG. HARN. T 0 ^ STOP-TAIL & B/U LP REAR WRG. HARN. ASM. (FC/FN9502 ONLY)J L '
DAII
B/U LFL FRJ ; ^VR.Gr; ! HARNr;.A S ^ . T 0 ]--- (DC/DN 9 5 0 2 ONLY)-L.H. FRAME
4 WAY CONN.----------- f;= I2 E M A IL
RAIL
I.STOP-TAIL & B/U LP REAR WRG. HARN. ASM
------------- R.H. SIDE-UNDER DASH
CONN.-INSTR. PNL. HARN. TO CAB WINDOW L IF T W IRE ASM
2 WAY
S IN G L E L IN E CONN. -----------------------------T E R M IN A L OR CONN. T E R M IN A T IO N
RELATED CIRCUITS
S P L IC E -----------------------------L IN E
*
BAT.
FUSE
BUS BAR
AUX.
ELECT EQUIP PNLrCONSOLE COMPT
FEED FOR M ULTIPLE CIRCUIT BREAKERS
ELECT EQUIP P N L; CONSOLE COMPT
C IR C U IT B R E A K E R - ----------------------------------
INSTR. PNL.HARN. TO ENG. HARN. ------------ R.H.SIDE-UNDER DASH
32 WAY CONN. (AS THRU JX)
O
(2 )
6 POST JCT (1 T H R U % )INSTR. PNL. HARN. TO TRAILER CABLE ASM. ELECT EQUIP PNLrCONSOLE COMPT.
2 WAY CONN.----------------INSTR. PNL.HARN. TO CLUTCH SW. WIRE ASM, -------- L.H.SIDE UNDER DASH
----- B RO KEN LIN E S DENOTE WRG & PARTS O TH ER TH AN STD & NOT IN STD WRG.
N O T E - A L L W IR E S B LA C K U N LESS O TH ERW IS E SPECIFIED.
S PARES -IN ENG.
HARN. FROM 32
WAY CONN. TO R.H.
FRAME R A IL AT
FRT. OF EN G IN E
----------- 1 SP A R E I (----------- 1 SPA RE 2 f---------H S P A R E 3 j~

------ -| S P A R E 4|
BAT. B O X H T R S.
6 ^ - /2
BAT. BOX.HTR.
<0>-H*
grn
--- (j--- < y >- ' / 4
~^ R E C E P T A C L E
r b c H l' F R A M E p ? 0 ^ l F R A M E
BATTERIES
(UPPER)
X W w J
BAT. BOX HTR.

(LO W E R)
O -VW A
>
.9
6V. 0 0 6 V.
j|> CIR. BRKE. MTG. BRKT.

CAB >|l
C N a a a a r j
|l> FRAME CAB GROUND

*8 -|l- ENGINE
STARTER
8 {AMM. SHU N T)
OOHI'FRTAME
--
-{j u }
14-
- /4B LK W HTTR-
am m eter
- f4 -
STARTER
ASM.
30A.
GENERATOR
10
FREQUENCY SENSING RELAY

GENERATOR
M AG N ETIC
S T A R T SW.
MASTER
CIRCUIT
BREAKER
-16-
16-
16HORN
10 RED
HORN B U T T O N
HORN
-px] /<-
-14 GRN-
-18
!!o
HORN RELAY
RADIO
I f o c iT o l I-----1 8 B LU E --- U S ----/8 B LU E ( D 18DK B L U E ~ [ ^ [RADIO SPKR.

-18 B RN B L K T R ----- l_ J T _ n Z T _ l\
*ia
^
- -O IRAD IO
16B R N B L K T R - 5 T - 18B R N B LK T R
\C.B.
io a
-16 WHT// R E D TR
'
16 W HT
//
RED T R
-\O f o f~ / 6 B L U E
, O IL PRESS.
]S E N D E R
- (o y| 1* 6 -
O IL PRESS. GA.
- 16 WHT // RED TR K> | 16CRN B LK T R ---- jc z j 16--- o T^ TeMF^

WATER T E M P 6 A.
GAUGES
_5-SENC)ER
-16 WHT // RED T R ---(o\ ^-/6B R N WHT CR T R [pz}-*6

F U E L GA.
16 W H T#RED T R ~ b | o'/6 WHT RED T R ----[bs]
EXH AU ST PYROMETER
[lON.
16 W H T// RED TR (o | ^ /6 RED B LK T R ----- [et]
CONTROL SW.
I6W H TIIR E D TR
'
ENG.OILTEM PGA,
( M.RHo
TACHOGRAPHS
Ol
|___
16 WHT//RED 77? rO IGN. j

- jO L T .
-I8G RA Y -
C IR C U IT
P O S IT IO N
RUN
BAT..IGN. ACC.
OFF LOCKED OPEN
'ACCESSORY
BAT. $ ACC.
A C C .____
LO. COOLANT
INDICATOR
L T .o --------
/8GRAY-
1------ c$-
' TACH O G RAPHS '
C O N TRO L SW.
LO, A IR SW. 1 1j-G ^ b
IGN
1
iH / t f - p ------1
---- 18 RED
16 W HT// RED TR
-16 B L K GRN TR-
-16-
L 0 COOLANT
tN m C A T O R ^
10 B R N B LK T R
18 RED WHTTR - 0 >6 B L K GRN TR

LO. AIR SW.
LO.AIRT.T.
ru
ACC.FEED RLY.
t8 RED WH T TR - @ -
ENG. ALARM
CONN.
____ I
-M-
16Y ELL H B LU E TR-
n
is w H T - - < ^ ) I6 W H T ------ -----1
LO. O IL T.T.
p i r - I8 G R N --- <3)--- 16 GR/V-{gx|#/<? - i
-16 RED WH T TR
.J
-/6 G R N W H T T R -
-18RED W HTTR
DIFF LOCK TT.
18 RED WHTTR @ /6GRN W HT CR T

DIFF LOCK T.T.
(TAN DEM A X L E )
_ ^ \ < 3 V ] A fJ - N P r- fl
ENG ALA RM BUZZ.

^ ^ - 1 6 GRN WHT TR
LO.WATER T.T.
LO. C O O LA N T
U L H !'
\ /
L L ___
PROBE
E J
H O T ENG.SW
R
W 6 -|l**
DIFF.
LOCKSW.
-[AZj- #/6
LO. O IL SW.
AIR P R E S S SW.
2SPD AXLE
SOL. AIR VALVE
3SPD AXLE
S O L. A IR V A L V E ',L
(3 S P EE D A X L E ) '
8 C.B.
STARTER SW.
16
-16 WHT // RED TR [eZ]-- %
GRN-
O FF-^
HTR.BLOWER
CONTROL SW.
i . S ^ A P T ER
- W -- 16L T GRN-
BACKUP LP
pO N
--- 16 GRN
-16 BRN - ~
-16 WHT//RED TR
S T A R T SW.
(CAB)
16
16-
AIRCOND.
' *
16 M ARO O N -
o ---- i s ----- -
RED SLEEVE-J
BACKUP
L P SW.
16-
FUEL
SHUTOFF
S O LEN O ID
BACKUP LP
FUEL SHUTOFF
16-
&
,[START
T SW. (AUX)
1616
'r ~
~jc s | ------ 16 -
COMPRESSOR
a CLUTCH
14 YELL---
A / t SW.
LO.
I6 0 R G
14 YELL14 BLUE WHT CR TR
14 B R N
HEATER
REAR BLOWER
[ R E S IS T O R
-------14 O R A N G E---
14 ORANGE
FRT. BLOWER
POW ERED
W INDO W SW.
POWERED
WINDOW
II C.B.
u p
--L
14 BLUE W HT T R -- (Y]---14 BLUE WHT TR--C
,i|----------- *i4 _ _
-14 RED WHT TR
- o = 30A
NOTE: SW. SHOWN WITH
o-i 14 BRN W HT TR ---O l,_14 BRN W14
HT TR
[*(0C
16 BLUE WHT CR TR.CLUTCH PEDAL IN NORMALl__ POWNj
i
POSITION.
. .
o ]qA W -/6BR N BLK TR 0s " cm(2)----- l6 - ^ '= ~ g - - /6 - - (g ) l6 B L U E W T C R T R --- [ZB|
ENG. BRKE. SW. * / 8 ^ % CLUTCH SW.
6r
JACOBS ENG.
BRAKE
CAB W IND O W
F L D j " ^ L I F T
(R.H.)
18GRAY
TACHO
18 GRAY-
18G RAY--- 0
I8GRAY-
SPEEDO.
j:- F U E L GA.
I8 G R A Y ----@ <: WATER TEMP GA.

18GRAY---- j! V O L T M E T E R
I8G R A Y"16 If
r?
- 18 GRA Y ---------1
O IL T E M P GA.
18
B R A K E A IR GA.
LIGHTING
L.H. H E A D LA M P
O IL PRESS. GA.
16 G R A Y----------
g ray
------ v
AM M ETER
-I6GRN' 14 RED
A IR GA.
v /------- 18GRA Y----- f 'sy<! A IR R E S T R IC T IO N GA.

>-/6GRAY
E XH AU ST PYRO M ETER
w
18 G RAY-
Cab, Engine,and
^ I N S T R . LP T A K E O F F
16 MAROON
--- I4 B L U E W H T C R T R
H EA D LA M PS
p I8 G R N W HT CR TR
B E A M T.T.
w-14 GRN WHT CR TR --------------
- *
C ,1 4 GRN WHT CR 7"/?Q - * 4 ---( j y
-14 GRN WHT CR TR 6
R.H. H E A D LA M P
-16 BRN WHT CR TR |cy]-- % -
MARKER LAMPS
-14 BRN B LK CR TR -
. 15 A .
VO LTM ETER
VOLTMETER
-16 RED
Chassis Wiring-DC/DN/FC/FN-9502-MD-5569
------(it''?)
SLE EPER
DOME LP
~!4
ORG B LK TR
'
MKR.
6 -C D -* ! 6 LP. SW.
0 F
\) 1- '
I6 B L U E
- / 6 G w 4 h ^ /6 - 0 - yC o X
F=\
v
-16 M ARO O N-hvh- / 6 h = H < 3 /
FLASHER
HAZARD | p <71
WARNING ! o 3
1
P O S IT IO N
R .H .T U R N l
P O S ITIO N
H6 BLUE
L - jS i- W H T
W ARNING SW
(N EU T POSITION)
!2 B L U E - S P A R E -------!2B LK -IC C . MKR. LPS. 3 .

-12B RN-TAIL LP S .------J o | ^
- I2 R E D - S T 0 P LPS.---- r 0^
-/2G R N -R H DIR. LPS. -<?
-12 YELL- L.H. DIR. LP S .---- :
l|----10 G R A Y ---------t||----- /4 W H T ---------
G R N -----
VJHT CR TR - C = A c V ''
-16 GRN
I
J
SEMI. T R L .P L U G
7 W IR E
NOTE- T R L . PLUGS
SHOWN LOOKING AT
1 OPEN MATING END
-I4 B LK - I.C .C MKR. L P S .- ^ . -J

14 B R N - TAIL LP S .----- SEMI. T R L .P L U G
-14 RED - 5 TOP LPS.---- S
6 W IR E
-14 GRN - R. H. DIR. L P --~/4 YELL - L.H. D IR LP.
L.H. FRT DIR.& PK.LP
-16 DK G R N - 18
\-<J?>-l8 B LK W HT S T R - k S J
I >6BRN-K 4 / 16BRN /
-DK
[c t }-- 716
-16 DK GRN
- I6 B R N -
4.
R.H. S T O P -T A IL
& DIR. LP
*/6----- 0 - ; ! ' L IC E N S E L P
DK BLUE-R E D LT BLUE
YELL:
L.H. TU RN l r Q !
P O S IT IO N ; c = S I
- a I.C.C. MKR. LPS. (BODY BUILDERS-REF)
L.H. DIR. T. T.
p 18 BLUE WHT CR TR
fc S !
o j
DIR & HAZARD
R.H.FRT DIR.&PK.LP
----- 18 BLUE -------- ^ - </S-|l' R.H. DIR. T. T.
^---- 16 M AROON ---

I
^
BRN\ 4 / - RED ------- GRN 2 ) ---- YELL J
- 16 YELL
UtlO-W--- 16 MAROON ----
DIRECTIONAL-HAZARD
$ STOP LAMPS
-------------
MOMO 0rA|
O F F ------- '
-16 RED -
A IR
STOP SW.
tan -
16 B R N ------- [ES]---- *6-
I60RG.
16 ORGr
^ 2 0 A ^
-GD-
CAB FRT. M KR. LPS.
SW.-
DOME LP
DOME LAMP
TRAILER CABLES
LL IG H T
-GRN
14 B RN WHT CR TR -
DIM.
-> 6 B LU E WHT C R TR
L-d > - / 8 B L K WHT STR-16 YELL
16
-16 YELL
-16 Y E L L ---d > ~ l 8
FRAME
L.H. S TO P-TAIL
& DIR. LP.
l\-GRD S TR A P '
f664576l
7-6361
SYM
TURN S IG N A L S W .8 P IG T A IL
COLOR
W = WHITE
T = TA N
TO L.H. L P S . ---------16 L BL.T O X ON F L A S H E R - -18 Y --T O R.H. L P S . --------- 16 D BL
-TURN S IG N A L SW.
R * RED
0 = O RA NG E
GR = G R EE N
BL = BLU E
BN s BROWN
BODYBUILDER'S CONNECTION
A G .R M 75000
___________________________________________
/LOW A/Q 8 U Z Z #
k
uo/?/v
_____ c
fi IA Y
fc )
u>
I
S O O Y 8 U /t-D # '5 V O O X V P ~ C / . A / ? A A / C , / 0 / V T /
M A fiK # t A M P S W /P
LOCAT/O/V- FYPOA/TLCTR/CAL EQU/PMENT PANEL

Body Builders ConnectionR Models7-5296
(See Opposite Side for T-5297)
5CHOOLBU5 / /TS.C.
BODY BUtLDERS CONNECT/ON
'5 "
<5#O M M T
DASU M A T
/ Z 4 jr A / f / ?
EA/G1NE //A/PA/ESS
+ F 0 6 1 7^/V/T \A //# (kfJ
*F/?F
5 / 6 COA/A/.
tf.H . D / # f ^ r O P /M M / ?
Z .M O /# /5 T O P M M P
W /'P ^ S
m /L, L/C^ A /SS, /O ^ A /77f
LOCATD/?.//.
S/D D 4 S // - (JA/DP
GLOV BOX
S A C K C //? 4 A f/= > W /& &
Body Builders ConnectionS and F.B.C. ModelsT-5297
BODY BUILDER'S CONNECT/ON

ALUM IN UM t/lt c a b s
L . H F R A M E RA/L (REF.)
TR A N SM /SSJO A t
( R E F .)
BODY BU/LDERS ROOKURCLEARAMCE, /DENT, fMARKER

L A M R S W /R E f/A/SJDE FRAME
RA/L
Body Builders ConnectionAluminum Tilt Cab Models7-5298
BODY BU/LDER'S COA/A/ECT/O/V HG,JG,

7SOOV f ALL "E"MODELS
EXCEPT SCHOOL BUS E d C.
/
Body Builder's ConnectionHG/HM /JG/ JM-7500; E ModelsExcept F.B.C.-T-5299
BODYBUILDER'S CONA/CT/ONALL STEEL T/LTCABS

___________________________________
Body Builders ConnectionSteel Tilt Cab ModelsT-5300

BODY 8U/LD#'5 C0/VA/CT/0/V ~

A ll W '/ J ; "C; / M "AIR M O D ELS
BODYBUJIDEP S
CLEAPAAJCB,
/DA/r?M4P/CPj|
LAMPS W /PE
/-/O O K U P-
^(/A/CT/OA/
P A /V ft -/?.M
P6A/P
OP CASCOPA/SP
Body Builders ConnectionH, J , C , and M Air ModelsT-5301
JUNCTION BLOCK
18BRN----- (
V -18BR N :
18Y _
18D G -.
18L G _
Engine W irin g - C M / K M -1500 -2500; C M -35 00 T-6330
(See O pposite Side for T-6331)
JUNCTION BLOCK
LT. FRT. MARKER LP.

RPO
Engine Wiring-CE/KE-1500 -2500; CE-3500 T-633I
JUNCTION BLOCK
18B-
Engine WiringCS -7500 -2500 -3500 T-6332

1 2 R
H
4B
X6B
JUNCTION
BLOCK
4B
16B
TO CLUTCH
HOUSING
12PPL-
TEMP
SW.
20DG
WITH RPO M35
12PPL - t - 12PPL
NEU SFT SW
/ (EXC W/RPO M35)
(RPOM35-38)
12DPL
. 20W/QR/PP
12PPL-
z:
18B/W
12R
FUSE j-
12R
IGNITION
fW
12R,
HUNT' 188*
AMMETER
RKMSTOR
TEMP OAGE a
AMMETER QAOE
aoDQ
IBB
18B/W
Engine WiringPS-1500 T-6333
RIGHT FRT. MARKER.

LP. CONN.
JUNCTION BLOCK
12R
BAT.
BRAKE WARNING
SW.
LEFT FRT. MARKER
LP. CONN.
HORN
Engine WiringPE/PS-2500 -3500 7-6334
Engine WiringCE-4500 -5500V T-6335
12R1SB/W^
18B-k
12R
SHUNT
AMMETER
RESISTOR
12R - g | !<
4B (250 ENG.)
6B (292 ENG.)
4B (250 ENG.)(
6B (292 ENG.)
tO H A M
IGNITION
AMMETER GAGE
Engine WiringPS-4500 T-6336

Engine WiringCE/M E -6500A /V
T-6340
WIRE
GAGE
14
MODELS
CE4500, 5500, 6500; ME6500
w/C.A. Dimension Over 120"
CE4500, 5500, 6500; ME6500
16
w/C.A. Dimension up to 119
All 1500 & 2500
18
* FOR WIRE GAGE - SEE CHART ABOVE.
f 18 Gage - 1500, 2500
o u ts id e f u e l t a n k m e te r
16 Gage - 4500, 5500, 6500
R. K. DIRECTION & TAIL LAMP
R. H. BACKING LAMP
16BRN
LICENSE LAMP
L.H. BACKING LAMP
DIRECTION Cr TAIL LAMP
Tail and Stop Lamp W i r i n g - C E / C M / C S / K E / K M - 1 500 -2500; CE-4500 -5 5 0 0 V ; CE / M E - 6 5 0 0 A / V T-6341

(See Opposite Side for 7-6342)
r . h . sid e
MARKER L P .'
18BRN/foJ\
18B
*18 GAGE W IRE-3500

16 G A G E W IRE-4500-5500-6500
I
^ - l8 B R N ^ jg
R. H. FRT. CORNER
MARKER LP.
R. H. CORNER MARKER LP.
18BRN
R. H. DIRECTION ft TAIL LP.

63
18BRN
18LG
IK H. BACKING LP.
1BERN
5^
DOME LP.
6
FUEL TANK
METER ASM.
18B |ll
C> 18BRN
18BRN-
S |)
LICENSE LP.
18BRN
CENTER MARKER LP.
18T
(ffi)
18BRN
18LG-
L.H. BACKING LP.

18BRN-
180R18W
18T
*BRN
*Y
*DG .
18LG.
18Y
18DG.
18LG.
O p ------ 18BRN ~
L. H. FRT. CORNER
MARKER LP.
- C X ^ 18BRN
L. H. DIRECTION & TAIL LP.

18BRNOT'
L. H. CORNER
i|j 18B
MARKER LP.
^
18BRN -\
L. H. SIDE
MARKER LP.
Tail and Stop Lamp WiringCE/CM/CS-3500; CE-4500 -5500V ; CE-6500V 7-6342
12PPL
12BRN
IGNITION SW.
CONN.
BLKHD
CONN
FUSE PNL
HEATER
LP.
W/S WASHER &
WIPER SW.CONN.
CLUSTER LP.
(20GY)
FUEL GA.
(20T)
__FUEL GA, FEED

(20P)
TEMP GA. LP.
(20DG)
BRAKE WARN. LP.
(20T)
CLUSTER LP.
(20GY)
R. H. DIR. SIG, LP.
(20DBL)
GEN. LP.
(20BRN)
__o il p r e s s ; LP.
(20DBL)
L. H. DIR. SIG. LP.
(20LBL)
CLUSTER LP.
(20GY)
HI BEAM IND. LP.
(20LG)
CLUSTER LP.
(20GY)
INSTRUMENT
CLUSTER
CIRCUIT
CONN.
180R
18W
18T----18BRN18Y----18D G 18 LG
-180R18W *18T
-18BRN18Y----18DG 18LG -
Instrument Panel W i r in g - C E / C M / C S - 1 5 0 0 -2500 -3500; K E / K M -1 5 0 0 -2500 T-6344

Instrument Panel W iring-CE-4500 -5500V T-6345
Instrument Panel WiringC E / M E - 6 5 0 0 A / V T-6349

18 DG
^ r20W/QR & PPL CR. TR.>
K L. H. TAIL STOP
H DIR SIG LAMP
CO
Cab, Engine, and Chassis WiringGE/GS-1500 -2500 T-6351
RELAY
BLOWER MOTOR
WIRE (Part of
Evaporator Asm. )
14DBL
16LBL
EVAPORATOR ASM
RESISTOR n n n
4
u T
n " T l 4D G X
DrVERTER
| ] j pHYsXcABLE
COMPRESSOR
SVv ITC lI (Normally
open contacts)
CONTROL SWITCH
SET AT: j CONNECTS:
B TO NONE
OFF
LOW 1 B TO L
B TO L & M
MED
HIGH 1 B TO L & H
14t
p^|
, 1 8 0 R -------- o U
16LBL
14BRN
CONTROL
SWITCH
CONNECTOR RECEPTACLE
"PANEL LIGHTS"
LEGEND
EXISTING WIRING
WIRING PART OF EQUIPMENT
AIR CONDITIONING WIRING
VIEWS INDICATE WIRE
ENTRY SIDE OF CONNECTOR
__'z
~ ~ rj
20GY------r
'
co co
ocn cn a u K l
il
a H
!R czicri c rr'I
|j
[} 120R '^
FUSE PANEL ASM

REPLACE EXISTING FUSE
WITH PROVIDED 25 AMP
FUSE
CONNEC TOR REC E PTAC LE

"CIG"
Air Conditioning W iring-CE/CM /CS/KE/KM -1500 -2500; T-6352

CE/CM/CS-3500; CE-4500V ; CE-5500V; CE/M E-6500A/V
Air Conditioning WiringGE/GS-J500 -2500 T-6353

X6905 1969 GMC Wiring Diagrams After August 12 1968

Uploaded by

Copyright:

Available Formats

X6905 1969 GMC Wiring Diagrams After August 12 1968

Uploaded by

Document Information

Copyright

Available Formats

Share this document

Share or Embed Document

Sharing Options

Did you find this document useful?

Is this content inappropriate?

Copyright:

Available Formats

X6905 1969 GMC Wiring Diagrams After August 12 1968

Uploaded by

Copyright:

Available Formats

X-6905

GMC TRUCK & COACH DIVISION

WIRING DIAGRAM INDEX

GASOLINE ENGINE MODELS

TORO-FLOW II DIESEL MODELS

(1) MD-3214 H.D. WIRING

SERIES 53, 71, and CUMMINS DIESEL MODELS

GRD.-ENONE-FRAME MTD. BAT.

[XJAL-6V BAT.-FRAME MTD.

SINGLE-12V. BAT.-FENDER MTD.

SINGLE-I2V. BAT.-FRAME MTD

STAR TER ASM.

Cab, Engine, and Chassis WiringEM-4500-5500M; SG-5500M/Y; SM-5500-6500M/Y ; SS-5500MMD-2840

-t4 0 K .e m . ------- CD --------------------------------- --2 SPEED AXLE ( WHEN USED )

AXLE SHIFT MTR.

- INSTR. PANEL HARN. TO ENG. H AR N. ( GAS M O D E LS )

-IN STR . PANEL H A R N .-

8 WAY M U LTIP LE CONNECTOR

-IN STR . PANEL HARN. TO EN G .H AR N.

- INSIDE CAB-UNDER IN S TR . PAN EL-UPPER R.H. SIDE

TO S T A R TE R INTER LO C K H A R N . ( D IESEL M O D ELS )-

ENG. HARN. TO HD.LR 8 PARKIN G L P HARN.

SHIFT SW. CABLE

INSTR. PANEL AT STEERING

SH IFT MOTOR C ABLE

-PART OF INSTR. PA N E L HARN. ( REE FOR BODY

JUNCTIO N BLOCK ( FU SIBLE

SINGLE LIN E C O N N E C T O R ------------

B LO C K ! LOA D PlC K-UP

TERM . OR CONNECTOR TER M IN A TIO N

- P A R T OF IN S T R . P A N EL H A R N .I REF. FOR BODY B U 'L D E R S )-

- REE FOR BODY B U IL D E R S ----------------- -----------------

PRO TECTO R FOR A M M E T E R

=AN EL~ N EAR

-AT 10 WAY M ULTIPLE C O NNE C TOR

-FUSE B L O C K -PART OF INSTR. PANEL HARN. ASM .

SP ECIFIED R.PO. DENOTE WRG. 8 PARTS OTHER THA N

STD, 8 NOT IN STD. WRG. HARN. A S M S,

BUS BA R PA RT OF FUSE B L O C K - F U S E BLO CK PART OF INSTR. PA NEL HARN. ASM .

AMMETER - R.PO. 1275 U 31

LOW AIR A L A R M B U ZZE R

J-------16 BLK. ------------ /4 7 -

BACK U P LP. SW.

DUAL SPD. W/S WIPER

- {4B LU EW H T. CR. TR.

RADIO RRO. 1276 - U 60

Cab , Engine, and Chassis H.D. Wiring-DLA/DLV-4000; TG-7500A/V-MD-3214

12 P O S T JCT. B LO C K L.H. ( * \ T H R U * I2 )----------------

12 P O S T JCT. BLOCK R. H f I THR l/ l2 ) W IR ES WITH RED S L E E V E -

TO S H IF T SW. TO MTR. C A BLE A S M .

INSTR, PANEL HARN.TO ENG. HARN. -D O M E LR

P N L. SUPT. FRT. S ILL BR K T .

CAB JCT. BE LO W FLO O R AT LH.FRT. S T E P

e WAY MULTIPLE CONNECTOR TO 2 4 WAY CONNECTORS - INSTR. PANEL HARN.

; WAY MULTIPLE CONNECTOR TO 2 - 4 WAY CONNECTORS - DIRECT SW ASM.

4 WAY MULTIPLE CONNECTOR -

IN STR.PAN EL HARN.TO ENG. ALARM HARN. -

3 WAY M ULTIPLE CONNECTOR -

INSTR. PANEL HARN.TO HD.LR 8 PARK.LP. HARN.

4 WAY MULTIPLE CONNECTOR -