KENR8979-01

May 2011

KENR8979-01 VOL 1 of 2
Wire Description
Wire Wire Wire Wire
Description Description
Number Color Number Color
Power Circuits Accessory Circuits Continued

101 RD Bat (+) (Not Application Specific) 518 OR Hazard Flasher To Switch

(Dimensions: 48 inches x 35 inches)

102 RD Head Lamp 521 YL A/C Switch To Refrigerant Switch

103 RD Power Batt (+) - Unswitched 522 WH A/C Clutch To Thermostat Switch

104 YL Auxilary Circuit 537 GN Turn Signal Switch To Flasher

105 RD Key Switch 552 WH Four Wheel Drive Solenoid

106 WH Auxilary Circuit 564 GY Rear Wiper Interrupt Switch To Wiper Sw.
111 YL Rear Horn Relay 568 GN Park Brake Warning Buzzer
112 PU PRM Module #1 569 PK A/C Switch Jumper #2
115 RD ACC Power Port 578 BU Auxiliary Washer
116 BR Rear Flood Lamp 585 YL Aux Hydraulic - Open
117 YL Rear Flood Lamp (ATCH) 586 BR Aux Hydraulic - Closed
118 GY Front Wiper 590 GY Intermittent Wiper

119 PK Rear Wiper C511 WH Relay Power

422E, 428E and 434E

122 BU Heater/AC Switch C568 WH Blower Motor
123 WH Quick Coupler E528 PU HVAC On/Off Switch To Blower Switch

Backhoe Loader
124 GN A/C Compressor E529 YL Blower Switch Jumper
125 OR Product Link Lighting Circuits

Electrical System
126 PK Laser Grade Check 601 GY Dash Lamp (Hi)
133 OR Advisory Display 603 PK Rotary Beacon
143 BR Ride Control Relay 604 OR Stop Lamp
144 GN Beacon 605 YL Turn Lamp - Left
146 GY PRM Module #1 606 GY Turn Lamp - Right 422E: 428E: 434E:
157 YL Front Flood Lamp (ATCH) 607 PK Flood Lamp - Front
MAW1-UP DPH1-UP SEF1-UP
158 BR Front Flood Lamp 608 GN Flood Lamp - Rear
159 BU Aux Ckt 610 OR Head Lamp - Basic
161 RD Aux Ckt 611 PU Head Lamp - High
180 GN Operator Seat 614 PU Park/Tail/Dash/Lamp

36 Page,
Ground Circuits 617 BR Tail/Position Lamp - Left (Road Package)
200 BK Main Chassis 618 YL Tail/Position Lamp - Right (Road Package)
202 BK Ground Control 619 GN Head Lamp - Low
207 BK Starter Diagnostic 620 WH Flood Lamp - Front
218 BK Start Relay 627 YL Fog Lamp
225 BK Hydro Solenoid To Sensor 630 GY Flood Lamp Rear (ATCH)
265 BK Electronic Pump Control Control Circuits

A250 BK MSS Indicator (Return) 702 OR AWD Switch to LH Brake Sw

Basic Machine Circuits 720 PU XMSN Brake Switch to AWD Relay
304 WH Starter Relay No. 1 Output 752 YL XMSN Forward Low Solenoid
306 GN Starter Relay Coil Or Key Switch 754 BU XMSN Reverse Solenoid
307 OR Key Switch To VMIS Sensor Module 762 YL Bucket Positioner Solenoid Switch
308 BK Main Power Relay Coil 766 GN XMSN Disconnect Solenoid
309 GY Alternator Regulator Terminal E727 BU Diode - Parking Brake Relay
310 PU Start Aid Switch To Start Aid Solenoid F739 GN Active Ride Control Switch (N.O.)
320 OR Horn Relay Coil To Switch G703 GN Load Check On
322 GY Warning Horn (Forward) G763 PU XMSN Neutral Switch Volume 1 of 2: Cab and Chassis
324 BU Differential Lock Solenoid G795 OR AWS Mode Switch To Rear Steer Switch
330 YL Neutral Start Relay Coil H764 GY Rear Steering Position Sensor
333 GN Scraper Key Switch 'R' Terminal H768 BR AWS Solenoid Ground 2
2011 Caterpillar, All Rights Reserved Printed in U.S.A.
367 BU Warning Horn - Rear H769 BR AWS Solenoid Ground 3
384 BU Relay To Glow Plugs H770 BR AWS Solenoid Ground
A305 YL Horn Power From Relay H771 BR Side Shift Lock Solenoid
A346 BU MSS Start Relay Interrupt J764 BR Switch/Sensor Return (8v)
A347 GN Diode Assy - Start Relay Interrupt (MSS) M719 GN Sideshift Left Switch
Monitoring Circuits M720 BU Sideshift Left Relay
403 GN Alternator (R) Terminal M721 WH Sideshift Right Switch
404 YL Opr Mon Hydraulic Oil Temperature P789 PK Alarm Horn Output
405 GY Opr Mon Oil Pressure (Low) U763 BU Circle Drive Control (Signal)
406 PU Opr Mon Coolant Temp X750 OR Fwd/Rev Solenoid Return From Controller
Harness And Wire Electrical Schematic Symbols
419 YL Signal Parking Brake NO X752 GY Reverse Solenoid Symbols
A 420 OR Opr Mon Fuel Filter/Low Accum Pressure A884 WH AWS Diode to Differential Lock Relay
432 PK Opr Mon Brake Pressure (Oil) F846 PU MSS Indicator LED Driver #1 (Red)

B 439 YL Water In Fuel Sensor G848 GN MSS Indicator LED Driver #2

T

441 OR Engine Coolant Temp Gage J881 YL Transmission Control State Pressure Temperature Level Flow Circuit Breaker
32 447 PK Fuel Level Gage 911 YL AWD Mode Switch Jumper Symbol Symbol Symbol Symbol Symbol
450 YL Tach Sender (+) 976 OR Ride Control Solenoid #1
452 PU Torque Converter 985 GY Crab Steer Solenoid Symbols and Definitions
D
F420 GN Warning Lamp (General) E917 WH Implement Lockout Switch To Ground (N.O.) Fuse: A component in an electrical circuit that will open the circuit if too much current flows
13
F443 GN Stability Warning Press Sw Out E918 GN Implement Lockout Switch To Ground (N.C.) through it.
1 16
G423 PK High Pressure Implement Filter - Rear E991 GY Multi-Function Output #3
Switch (Normally Open): A switch that will close at a specified point (temp, press, etc.). The
Accessory Circuits G981 PU Travel Alarm Disable
10 36 circle indicates that the component has screw terminals and a wire can be disconnected from it.
500 BR Wiper - Front (Park) M936 BR Flow Control Switch
3
11 501 GN Wiper - Front (Low) M937 GN Flow Control Prox Sw #1 Switch (Normally Closed): A switch that will open at a specified point (temp, press, etc.).
6 7 No circle indicates that the wire cannot be disconnected from the component.
2 502 OR Wiper - Front (Hi) N939 GN Ride Control Solenoid #2 (On)
503 BR Wiper - Rear (Park) N945 OR AWD Sw to AWD Relay Ground (Wired): This indicates that the component is connected to a grounded wire. The
506 PU Washer - Front N957 PK RS-232 RXD - COMM #1 grounded wire is fastened to the machine.
507 WH Washer - Rear N960 OR RS-232 TXD - COMM #1
Ground (Case): This indicates that the component does not have a wire connected to ground.
508 PU Radio Speaker - Left N970 YL RS-232 DTR - COMM #1
It is grounded by being fastened to the machine.
509 WH Radio Speaker - Left (Commom) N973 BR RS-232 DCD - COMM #1
511 BR Radio Speaker - Right N979 GN RS-232 Signal Ground - COMM #1 Reed Switch: A switch whose contacts are controlled by a magnet. A magnet closes the
contacts of a normally open reed switch; it opens the contacts of a normally closed reed switch.
512 GN Radio Speaker - Right (Common) P915 PK Indicator - Transmission Neutral
513 OR A/C Compressor/Refrigerant Pressure Sw. R912 OR Hydraulic Pedal Lock Solenoid
Sender: A component that is used with a temperature or pressure gauge. The sender
515 GY Blower Motor (HI) X977 YL Fuel Pump +V Supply measures the temperature or pressure. Its resistance changes to give an indication to
T
the gauge of the temperature or pressure.
516 GN Blower Motor (MEDIUM)
517 BU Blower Motor (Low)
Relay (Magnetic Switch): A relay is an electrical component that is activated by electricity.
It has a coil that makes an electromagnet when current flows through it. The
electromagnet can open or close the switch part of the relay.

Solenoid: A solenoid is an electrical component that is activated by electricity. It has a

coil that makes an electromagnet when current flows through it. The electromagnet
can open or close a valve or move a piece of metal that can do work.

Magnetic Latch Solenoid: A magnetic latch solenoid is an electrical component that is

activated by electricity and held latched by a permanent magnet. It has two coils (latch and unlatch)
that make electromagnet when current flows through them. It also has an internal switch that places
the latch coil circuit open at the time the coil latches.

Harness and Wire Symbols

Wire, Cable, or Harness Harness Identification Letter(s):
Assembly Identification: Includes (A, B, C, ..., AA, AB, AC, ...)
Harness Identification Letters and
Harness Connector Serialization Code:
Harness Connector Serialization
The "C" stands for "Connector" and the
Codes (see sample).
number indicates which connector in the
AG-C4 L-C12 harness (C1, C2, C3, ...).
Component Location Volume 1 L-C12
111-7898 3E-5179 3E-5179
Schematic Machine Schematic Machine
Component Component
Location Location Location Location Part Number: for Connector Plug 1
Part Number: for Connector Receptacle
16 Alarm - Action D-14 B Switch - Beacon D-13 B
2
Cluster - Gauge D-14 B Switch - Brake (LH) H-8 A
Control - FNR G-8 A Switch - Brake (RH) G-8 A Plug Receptacle
Diode - Arc Suppressor (Fuel Lift Pump) C-5 D Switch - Bucket Position (ATCH) F-1 36 Pin or Socket Number
5A
Diode - Arc Suppressor (Ride Cntrl) ATCH C-5 32 Switch - Column Multi Function G-8 A 1 Deutsch connector: Typical representation
Component
Ground - Control C-6 6 Switch - Differential Lock H-8 16 of a Deutsch connector. The plug contains all Fuse (5 Amps) 9X-1123 Part Number
2 sockets and the receptacle contains all pins.
10 Ground - Lower Cab C-6 6 Switch - Front Work Lamp (ATCH) E-13 B
7 325-AG135 PK-14
Module - PRM 1 I-5 D Switch - Hazard F-8 A Sure-Seal connector: Typical representation
1 Harness identification code:
Module - PRM 2 I-4 D Switch - Horn C-13 B of a Sure-Seal connector. The plug and receptacle This example indicates wire group 325, Wire Gauge
2 contain both pins and sockets. wire 135 in harness "AG". Wire Color
A Module - PRM (HVAC) I-4 D Switch - Key C-14 B
13 Motor - Seat Group G-3 13 Switch - Load Check Disable H-7 A
6 Port - Power E-11 B Switch - Neutralizer (loader handle) G-3 B
Relay - AWD G-5 D Switch - Neutralizer (xmsn handle) G-3 B
Relay - Flasher D-5 D Switch - Park Brake F-11 B
11
1 Relay - Fuel Lift Pump C-5 D Switch - Power Side Shift F-13 B
Relay - Horn (Fwd) H-5 D Switch - Pressure (Ride Control) (ATCH) H-1 32
32 Relay - Horn (Rear) G-5 D Switch - Rear Fog Lamp D-13 B
36
Relay - Neutral Lock Alarm C-5 D Switch - Rear Wiper C-13 B
Relay - Neutral Start D-5 D Switch - Rear Work Lamp (ATCH) D-13 B
B Relay - Neutralizer D-5 D Switch - Return to Dig F-2 36
Relay - Park Brake Alarm C-5 D Switch - Ride Control G-7 A
3
D Relay - Ride Control F-5 D Switch - Roading G-7 A
Sensor - Bucket Position ATCH F-2 36 Switch - Side Shift Lock F-13 B
2 Solenoid - Return to Dig F-2 1 Switch - Stabilizer Alarm Group (ATCH) G-13 B
Solenoid - Ride Control 1 H-1 32 Switch - Start Aid C-13 B
Solenoid - Ride Control 2 H-1 32 Switch - STD Front Work Lamp F-14 B Related Electrical Service Manuals
Switch - AWD H-7 A Switch - STD Rear Work Lamp E-14 B Title Form Number
Switch - AWD (Italy) H-7 A Switch - Transmission Lock I-7 A Electric Starting Motor: 143-0539 SENR3828
Machine locations are repeated for components located close together.
Machine Troubleshooting: KENR8849
A = Located inside cab.
Engine Troubleshooting: KENR6900
B = Located inside right console.
D = Located in or near relay panel.

Resistor, Sender and Solenoid Specifications

Part No. Component Description Resistance (Ohms)
134-2540 Resistor: CAN Terminating 120
54C (130F) - 560 to 716
244-3106 Sender: Coolant Temperature
110C (230F) - 72 to 82
54C (130F) - 560 to 716
4W-9972 Sender: Converter Temperature
110C (230F) - 72 to 82
MACHINE CONNECTOR & COMPONENT LOCATIONS 303-2933 Sender: Fuel Level (Non-EST)
Empty - 246-252
Full - 27-33
At room temperature unless otherwise noted.

Connector Location Volume 1

Schematic Machine
Connector Number
Location Location
CONN 1 D-14 B
CONN 3 H-12 1
CONN 4 H-12 1
CONN 6 C-11 B
CONN 7 C-11 B
Off Machine Switch Specification
CONN 8 C-11 B
Part No. Function Actuate Deactuate Contact Position
3000 kPa MAX @ -40 C 2387 .345 kPa @ -40 C
CONN 9 D-11 B 311-7711 Boosted Brake Pressure Normally Closed
(435.1 psi) to +121 C (346 0.05 psi) to +121 C
CONN 10 D-11 B
CONN 11 E-11 B
CONN 12 J-12 3
CONN 13 J-12 3
CONN 15 E-8 6
CONN 18 E-3 6
CONN 19 E-3 6
CONN 20 F-3 2
CONN 21 G-3 6
CONN 22 H-3 6
CONN 24 J-3 7
CONN 26 J-3 6
The connectors shown in this chart are for harness to harness connectors.
Connectors that join a harness to a component are generally located at or near
the component. See the Component Location Chart.
 14 13 12 11 10 9 8 7 6 5 4 3 2 1
KENR8979-01 VOL 1 of 2

J J
(Dimensions: 48 inches x 35 inches)

PM-C32
1552272
105-PM18 RD - 18 1 CONN 26
H1 H1 202-PM31 BK - 18 2 TO PRODUCT LINK HARN
308-PM37 YL - 18 3 CONN WT-C1
450-PM185 YL - 18 4 (VOL 2 LOC B-5)

105-PM32 RD - 18
PM-C6 105-PM18 RD - 18
1552252 PM-C3
123-PM150 WH - 18 308-PM124 YL - 18 308-PM124 YL - 18 308-PM124 YL - 18 1673692
1 119-PM166 PK - 14 105-PM30 RD - 18 123-PM143 WH - 18 200-PM108 BK - 18 200-PM108 BK - 18 200-PM108 BK - 18
2 503-PM177 BR - 16 118-PM148 GY - 16 143-PM68 BR - 18 308-PM106 YL - 18 308-PM106 YL - 18 TO BATTERY CABLE 123-PM150 WH - 18 1
3 564-PM224 GY - 16 119-PM166 PK - 14 180-PM238 GN - 14 200-PM46 BK - 18 200-PM46 BK - 18 BUSS BAR (SH 2 LOC E-4) 202-PM65 BK - 18 2
CONN 13 4 118-PM148 GY - 16 123-PM6 WH - 18 200-PM7 BK - 18 275-0570 WITH AIR CON 322-PM167 GY - 18 3
5 123-PM6 WH - 18 500-PM203 BR - 16 200-PM94 BK - 18 275-0553 WITHOUT AIR CON 441-PM38 OR - 18 4
TO ROOF HARN 6 500-PM203 BR - 16 501-PM179 GN - 16 102-PM176 RD - 14 102-PM176 RD - 14 200-PM104 BK - 18 452-PM139 PU - 18 5
CONN TP-C12 7 501-PM179 GN - 16 502-PM34 OR - 16 143-PM63 BR - 18 143-PM63 BR - 18 PM-C21 200-PM110 BK - 18 447-PM156 PK - 18 6

I (VOL 2 LOC G-10) 8

9
10
502-PM34
590-PM192
506-PM252
OR - 16
GY - 18
PU - 18
503-PM177
506-PM252
564-PM224
BR - 16
PU - 18
GY - 16
102-PM176
143-PM63
RD - 14
BR - 18
143-PM126 BR - 18 143-PM126 BR - 18

202-PM40 BK - 18
1552269
702-PM193 OR - 18
911-PM196 YL - 18
1
2
NOTE R
200-PM234
200-PM240
202-PM3
BK - 14
BK - 14
BK - 18
PRM MODULE 1
276-7290
PRM MODULE 2
276-7291
PRM MODULE HVAC
276-7287
521-PM226
552-PM162
754-PM208
YL - 18
WH - 18
BU - 18
7
8
9
I
11 590-PM192 GY - 18 143-PM126 BR - 18 202-PM52 BK - 18 202-PM31 BK - 18 +BAT +BAT +BAT 752-PM212 YL - 18 10 CONN 24
202-PM161 BK - 18 202-PM83 BK - 18 202-PM65 BK - 18 PRM FUSES 506-PM116 PU - 18
12 11 TO ENGINE HARN
603-PM237 PK - 16 308-PM109 YL - 18 202-PM186 BK - 18 202-PM92 BK - 18 30A 274-9872 40A 507-PM114 WH - 18 12 CONN EF-C26
607-PM235 PK - 16 552-PM162 WH - 18 202-PM161 BK - 18 202-PM8 BK - 18 202-PM113 BK - 18 40A 278-6377 306-PM101 GN - 18 13 (SH 2 LOC H-4)
608-PM236 GN - 16 202-PM188 BK - 18 202-PM119 BK - 18 14
620-PM231 WH - 16 601-PM15 GY - 16 60A 267-2701
218-PM24 BK - 18 405-PM122 GY - 18 15
PM-C22
630-PM233 GY - 16 610-PM204 OR - 14 308-PM109 YL - 18 308-PM109 YL - 18 766-PM175 GN - 18 30A 60A 40A 218-PM24 BK - 18 16
1552273
614-PM218 PU - 18 552-PM162 WH - 18 552-PM162 WH - 18 G763-PM257 PU - 18 265-PM66 BK - 18 406-PM27 PU - 18 17
1 603-PM237 PK - 16 702-PM131 OR - 18 601-PM15 GY - 16 601-PM15 GY - 16 614-PM191 PU - 18 18
CONN 12 2 620-PM231 WH - 16 766-PM175 GN - 18 610-PM204 OR - 14 610-PM204 OR - 14 306-PM101 GN - 18 PM-C29 PM-C30 PM-C31 439-PM70 YL - 18 19
3 608-PM236 GN - 16 911-PM5 YL - 18 8 1 3 4 6 10 308-PM117 YL - 18 2304011 30 2304011 30 2304011 30 20
TO ROOF HARN 85 1
85 1
85 1
CONN TP-C1 4 607-PM235 PK - 16 F739-PM152 GN - 18 614-PM147 PU - 18 308-PM37 YL - 18 308-PM17 YL - 18 1 1 1 450-PM67 YL - 18 21
5 105-PM30 RD - 18 G763-PM257 PU - 18 614-PM218 PU - 18 614-PM191 PU - 18 XMSN LOCK SW 309-PM95 GY - 18 200-PM9 BK - 18 2 2 2 2 2 2 432-PM168 PK - 18 22
(VOL 2 LOC F-10) 86 86 86
6 630-PM233 GY - 16 N945-PM228 OR - 18 614-PM189 PU - 18 214-4716 310-PM93 PU - 18 324-PM19 BU - 18 23
PM-C43 322-PM167 GY - 18 87 87A 87 87A 87 87A 24
702-PM131 OR - 18 702-PM193 OR - 18 7 2 5 9 2285856 324-PM19 BU - 18 X750-PM23 OR - 18 25
102-PM170 RD - 14 702-PM194 OR - 18 405-PM122 GY - 18 RELAY RELAY RELAY 26
102-PM170 RD - 14 102-PM176 RD - 14 202-PM40 BK - 18 406-PM27 PU - 18 27
102-PM176 RD - 14 111-PM73 RD - 18 766-PM175 GN - 18 766-PM175 GN - 18 308-PM109 YL - 18 420-PM169 OR - 18 420-PM169 OR - 18 28
102-PM246 RD - 14 111-PM74 RD - 18 202-PM52 BK - 18 432-PM168 PK - 18 310-PM93 PU - 18 29
118-PM45 GY - 16 911-PM5 YL - 18 911-PM195 YL - 18 439-PM70 YL - 18 USB SB USB SB USB SB 309-PM95 GY - 18 30
36 Page,

105-PM18 RD - 18 143-PM63 BR - 18 911-PM196 YL - 18 447-PM156 PK - 18 NOTE T X977-PM254 YL - 18 31

105-PM32 RD - 18 143-PM126 BR - 18 450-PM67 YL - 18
105-PM60 RD - 16 143-PM157 BR - 18 F739-PM152 GN - 18 F739-PM152 GN - 18 450-PM185 YL - 18
105-PM30 RD - 18 159-PM100 BU - 16 G763-PM257 PU - 18 G763-PM257 PU - 18 AWD ITALY SW 452-PM139 PU - 18 112-PM10 PU - 10
105-PM62 RD - 16 161-PM103 RD - 16 N945-PM228 OR - 18 N945-PM228 OR - 18 283-7616 441-PM38 OR - 18 112-PM20 PU - 10
PM-C16 200-PM1 BK - 18 506-PM116 PU - 18 146-PM36 GY - 10 146-PM36 GY - 10
1552252 NOTE X RK-C5
111-PM41 RD - 16 200-PM44 BK - 18 507-PM114 WH - 18 146-PM47 GY - 10 146-PM47 GY - 10
1 617-PM125 BR - 18 111-PM73 RD - 18 202-PM43 BK - 18 521-PM226 YL - 18 103-PM35 RD - 10 103-PM35 RD - 10 1552269
CONN 4 2 367-PM11 BU - 18 111-PM74 RD - 18 202-PM161 BK - 18 552-PM162 WH - 18 H1 103-PM39 RD - 10 103-PM39 RD - 10 N939-RK9 GN - 18 1 RIDE CONT ARC SUPPR
3 604-PM209 OR - 18 202-PM164 BK - 18 143-PM126 BR - 18 200-RK10 BK - 18 2 189-3158
TO REAR HARN - STD
CONN RT-C8
4
5
605-PM211
606-PM210
YL - 18
GY - 18 143-PM181 BR - 18
115-PM190 RD - 18
116-PM243 BR - 16
115-PM190 RD - 18
116-PM243 BR - 16
202-PM165
202-PM174
BK - 18
BK - 18
N945-PM228
911-PM195
OR - 18
YL - 18
605-PM89
606-PM50
YL - 18
GY - 18
POWER DISTRIBUTION BLOCK
(VOL 2 LOC G-12) RK-C2
6 618-PM149 YL - 18 200-PM182 BK - 18 117-PM242 YL - 16 117-PM242 YL - 16 308-PM75 YL - 18 614-PM189 PU - 18 552-PM42 WH - 18 611-PM51 PU - 14
7 627-PM206 YL - 18 200-PM159 BK - 14 308-PM109 YL - 18 617-PM215 BR - 18 1552269
OR 8 1 3 4 6 10 RIDE CTRL SOL 1
8 754-PM77 BU - 18 202-PM260 BK - 18 118-PM148 GY - 16 118-PM45 GY - 16 308-PM202 YL - 18 618-PM217 YL - 18 102-PM246 RD - 14 102-PM246 RD - 14 123-RK2 WH - 18 123-RK2 WH 18
- N939-RK6 GN - 18 1 RD-18
9 200-PM159 BK - 14 367-PM11 BU - 18 118-PM180 GY - 16 320-PM128 OR - 18 AWD SW 619-PM213 GN - 14 104-PM197 RD - 18 104-PM197 RD - 18 200-RK3 BK - 18 2 RD-18 238-4628
TO REAR HARN - MECH EST PM-C40 RK-C1
CONN RM-C8
10 432-PM259 PK - 18 432-PM259 PK - 18 324-PM19 BU - 18 214-4692 752-PM212 YL - 18 105-PM60 RD - 16 105-PM60 RD - 16 200-RK1 BK - 18 200-RK3 BK 18 -
11 202-PM260 BK - 18 604-PM209 OR - 18 119-PM166 PK - 14 119-PM241 PK - 16 330-PM29 YL - 18 754-PM208 BU - 18 111-PM41 RD - 16 111-PM41 RD - 16 1552272 3E3376 200-RK8 BK 18 -
(VOL 2 LOC I-12) NOTE X RK-C4

H H
12 H771-PM145 BR - 18 605-PM211 YL - 18 119-PM239 PK - 16 419-PM25 YL - 18 PM-C45 766-PM82 GN - 18 115-PM190 RD - 18 115-PM190 RD - 18 F739-PM152 GN - 18 1 123-RK2 WH - 18 200-RK10 BK - 18
606-PM210 GY - 18 500-PM203 BR - 16 7 2 5 9 2285856 766-PM112 GN - 18 161-PM103 RD - 16 161-PM103 RD - 16 200-PM104 BK - 18 2 200-RK1 BK - 18 1552269
123-PM6 WH - 18 123-PM2 WH - 18 501-PM179 GN - 16 976-PM98 OR - 18 N939-PM136 GN - 18 3 N939-RK5 GN - 18 N939-RK5 GN - 18 N939-RK6 GN 18
- N939-RK7 GN - 18 1 RD-18 RIDE CTRL SOL 2
617-PM125 BR - 18 123-PM79 WH - 18 502-PM34 OR - 16 202-PM186 BK - 18 F739-PM152 GN - 18 601-PM12 GY - 16 601-PM12 GY - 16 976-PM98 OR - 18 4 976-RK4 OR - 18 N939-RK7 GN 18
- 200-RK8 BK - 18 2 RD-18 238-4628
618-PM149 YL - 18 123-PM143 WH - 18 506-PM255 PU - 18 702-PM194 OR - 18 N939-PM137 GN - 18 601-PM13 GY - 16 601-PM13 GY - 16 N939-RK9 GN 18
-
PM-C38 627-PM206 YL - 18 123-PM150 WH - 18 518-PM120 OR - 16 PM-C28 552-PM162 WH - 18 N939-PM136 GN - 18 601-PM14 GY - 16 601-PM14 GY - 16 CONN 22
CONN 3 1552272 754-PM77 BU - 18 537-PM219 GN - 18 2059362
DIFF LOCK SW
202-PM83 BK - 18 X750-PM23 OR - 18 614-PM26 PU - 18 614-PM26 PU - 18 976-RK4 OR - 18 976-RK4 OR 18
- RK-C3
1552267
1 143-PM181 BR - 18 H771-PM145 BR - 18 124-PM227 GN - 18 124-PM227 GN - 18 537-PM230 GN - 18 G795-PM135 OR - 18 1 X977-PM254 YL - 18 617-PM214 BR - 18 617-PM214 BR - 18
TO POWER SIDESHIFT HARN 2 200-PM182 BK - 18 M719-PM183 GN - 18 133-PM84 OR - 16 133-PM84 OR - 16 552-PM162 WH - 18 324-PM19 BU - 18 2 204-0775 618-PM216 YL - 18 618-PM216 YL - 18 123-RK2 WH - 18 A BK-18 RC PRESS SW
CONN PE-C1 3 M719-PM183 GN - 18 M721-PM184 WH - 18 590-PM192 GY - 18 B RD-18
(VOL 2 LOC E-12) 304-5696
4 M721-PM184 WH - 18 143-PM68 BR - 18 NOTE: OPTIONAL RIDE CONTROL SW MAY BE PM-C41 976-RK4 OR - 18 C BU-18
143-PM99 BR - 18 601-PM15 GY - 16 REPLACED WITH LOAD CHECK DISABLE SW 2929784
143-PM138 BR - 14 604-PM71 OR - 18
143-PM63 BR - 18 604-PM72 OR - 18 102-PM246 RD - 14 H1
143-PM181 BR - 18
143-PM140 BR - 18
143-PM126
143-PM157
BR - 18
BR - 18
605-PM90
605-PM91
YL - 18
YL - 18
PM-C8
1082253
104-PM197
104-PM198
RD - 18
RD - 18
104-PM198 RD - 18
104-PM199 RD - 18 BACKLIGHT F1
RIDE CONTROL - ATCH
LOAD CHECK DISABLE SW D1 C1 B1
605-PM172 YL - 18 604-PM71 OR - 18 A 104-PM199 RD - 18 10A 601-PM13 GY - 16 601-PM13 GY - 16

MOM
144-PM187 GN - 16 144-PM187 GN - 16 606-PM86 GY - 18 702-PM131 OR - 18 B BRAKE SW LH 253-9395 104-PM200 RD - 18 A1 AA1

86

30
157-PM244 YL - 16 157-PM244 YL - 16 606-PM87 GY - 18 111-PM73 RD - 18 C 105-8034 104-PM201 RD - 18 FWD HORN RLY 614-PM26 PU - 18 614-PM26 PU - 18
158-PM245 BR - 16 158-PM245 BR - 16 606-PM171 GY - 18 105-PM60 RD - 16 146-9439 PM-C18
610-PM115 OR - 14 NOTE E 111-PM41 RD - 16 K1 3E3376
161-PM103 RD - 16 610-PM204 OR - 14 115-PM190 RD - 18 F2 976-PM21 OR - 18

87A
LH TAIL 1

87

85
611-PM49 PU - 18 116-PM243 BR - 16 601-PM14 GY - 16 601-PM14 GY - 16 IF LOAD CHECK DISABLE IS INSTALLED,
STABILIZER GP 611-PM85 PU - 14
NOTE: CONNECT LOAD CHECK DISABLE SW
TO PM-C12 IF REQUIRED. 117-PM242 YL - 16 322-PM167 GY - 18
D2 C2 B2
A2
10A
AA2 CONN 22 2
3 INSTALL JUMPER TO PLATFORM CONN
PM-C7 PM-C40 (SH 1 LOC H-3)
228-4595 200-PM1 BK - 18 614-PM4 PU - 18
1082253
118-PM180 GY - 16 320-PM128 OR - 18 617-PM214 BR - 18 617-PM214 BR - 18 4
200-PM97 BK - 18 200-PM44 BK - 18 614-PM173 PU - 18 119-PM241 PK - 16
200-PM182 BK - 18 200-PM94 BK - 18 614-PM218 PU - 18 604-PM72 OR - 18 A F739-PM152 GN - 18 123-PM2 WH - 18 104-PM200 RD - 18
PM-C25 200-PM159 BK - 14 200-PM110 BK - 18 619-PM213 GN - 14 720-PM130 PU - 18 B BRAKE SW RH 614-PM147 PU - 18 123-PM79 WH - 18 104-PM201 RD - 18 RH TAIL F3
3E3364 D3 C3 B3
200-PM220 BK - 14 702-PM131 OR - 18 111-PM74 RD - 18 C 105-8034 124-PM227 GN - 18 10A 601-PM12 GY - 16 601-PM12 GY - 16
1 G981-PM127 PU - 18 8 1 3 4 6 10 133-PM84 OR - 16 A3 AA3

86

30
2 J881-PM121 YL - 18 G981-PM127 PU - 18 G981-PM142 PU - 16 G981-PM142 PU - 16 200-PM221 BK - 18 200-PM221 BK - 18 720-PM130 PU - 18 NOTE E RIDE CONTROL SW 143-PM99 BR - 18 REAR HORN RLY 618-PM216 YL - 18 618-PM216 YL - 18 PM-C11
G981-PM133 PU - 18 752-PM212 YL - 18 214-4719 143-PM138 BR - 14 146-9439 115-PM190 RD - 18 115-PM190 RD - 18 1552269
LH STAB LEG UP J881-PM121 YL - 18 202-PM256 BK - 18 754-PM28 BU - 18 144-PM187 GN - 16 K2 105-PM60 RD - 16 105-PM60 RD - 16 180-PM238 GN - 14 1 MOTOR
J881-PM121 YL - 18 J881-PM121 YL - 18 J881-PM123 YL - 18 202-PM178 BK - 18 766-PM175 GN - 18 NOTE P 157-PM244 YL - 16 F4 200-PM234 BK - 14 SEAT GROUP

87A
PM-C12 KEY 2

87

85
J881-PM123 YL - 18 J881-PM123 YL - 18 202-PM69 BK18- 202-PM61 BK
- 18 911-PM5 YL - 18 FNR CONTROL 7 2 5 9 2285856 158-PM245 BR - 16 D4 C4 B4
10A 103-PM48 RD - 14 314-4290
PM-C26 202-PM160 BK - 18 F739-PM152 GN - 18 PM-C10 159-PM100 BU - 16 367-PM11 BU - 18 A4 AA4
3E3364 1552273 310-9356
105-PM62 RD - 16 202-PM65 BK - 18 G763-PM257 PU - 18 202-PM8 BK - 18 161-PM103 RD - 16 A305-PM151 YL - 18
1 G981-PM133 PU - 18 115-PM190 RD - 18 202-PM31 BK - 18 G795-PM135 OR - 18 308-PM202 YL - 18 1 143-PM63 BR - 18 180-PM238 GN - 14
2 J881-PM123 YL - 18 116-PM243 BR - 16 202-PM113 BK - 18 752-PM212 YL - 18 2 200-PM9 BK - 18
117-PM242 YL - 16 202-PM164 BK - 18 N945-PM228 OR - 18 754-PM28 BU - 18 3 F 200-PM46 BK - 18 ACC SKT F5 PM-C33
RH STAB LEG UP N D5 C5 B5 1552269
119-PM239 PK - 16 202-PM207 BK - 16 330-PM29 YL - 18 4
N
610-PM204 OR - 14 200-PM105 BK - 18 10A 103-PM53 RD - 14 NUETRALIZER SW XMSN HANDLE
124-PM227 GN - 18 320-PM128 OR - 18 5 R 601-PM15 GY - 16 200-PM108 BK - 18 A5 AA5 766-PM82 GN - 18 1
263-7261
133-PM84 OR - 16 202-PM43 BK
- 18 200-PM44 BK - 18 6 200-PM222 BK - 18 202-PM92 BK - 18 2

G G
143-PM140 BR - 18 202-PM174 BK - 18 8 1 3 4 6 10 200-PM258 BK - 18
144-PM187 GN - 16 202-PM165 BK - 18 HORN ROADING SW 202-PM61 BK - 18
157-PM244 YL - 16 202-PM260 BK - 18 202-PM3 BK - 18 214-4711 202-PM102 BK - 18 BRAKE LAMPS F6
158-PM245 BR - 16 202-PM144 BK - 18 202-PM92 BK - 18 202-PM160 BK - 18 D6 C6 B6
15A 103-PM58 RD - 14 103-PM39 RD - 10
200-PM97 BK - 18 202-PM161 BK - 18 PM-C37 202-PM178 BK - 18 A6 AA6
STABILIZER ALARM - ATCH 200-PM221
202-PM69
BK - 18
BK
- 18
202-PM119
202-PM229
BK - 18
BK - 16
7 2 5 9 2285856 202-PM256
306-PM101
BK - 18
GN - 18
PM-C36
1552269
NEUTRALIZER SW LOADER HANDLE
202-PM144 BK - 18 SW COLUMN MULTI FUNCTION 202-PM188 BK - 18 307-PM118 OR - 18 720-PM130 PU - 18 766-PM112 GN - 18 1
9R-9868
307-PM146 OR - 16 307-PM118 OR - 18 273-9190 102-PM176 RD - 14 307-PM163 OR - 18 911-PM5 YL - 18 D7 C7 B7
HORN RELAYS F7 202-PM3 BK - 18 2
308-PM59 YL - 16 307-PM146 OR - 16 307-PM163 OR - 18 308-PM17 YL - 18 10A 103-PM76 RD - 14
309-PM95 GY - 18 308-PM106 YL - 18 A7 AA7

86

30
310-PM93 PU - 18 308-PM37 YL - 18 308-PM124 YL - 18 AWD RLY 104-PM197 RD - 18 104-PM197 RD - 18
405-PM122
406-PM27
GY - 18
PU - 18
308-PM75
308-PM109
YL - 18
YL - 18
PM-C9
1552264 FRONT DASH PANEL 308-PM132
308-PM247
YL - 18
YL - 18
146-9439
K4
111-PM41 RD - 16
161-PM103 RD - 16
111-PM41 RD - 16
161-PM103 RD - 16 PM-C1
419-PM55 YL - 18 308-PM202 YL - 18 619-PM213 GN - 14 56b
320-PM128 OR - 18 F8 1552264

87A
1 YL HEADLIGHT HAZARD

87

85
56 FLASH
420-PM169 OR - 18 308-PM117 YL - 18 610-PM115 OR - 14 2 WH/YL TURN SIGNALS 322-PM167 GY - 18 D8 C8 B8
15A 103-PM78 RD - 14 103-PM35 RD - 10 611-PM51 PU - 14 1
15/1
432-PM134 PK - 18 308-PM59 YL - 16 308-PM17 YL - 18 102-PM170 RD - 14 3 BK/PU 330-PM64 YL - 18 N945-PM228 OR - 18 A8 AA8 200-PM240 BK - 14 2
439-PM70 YL - 18 308-PM106 YL - 18 605-PM90 YL - 18 4 PU/GN
L
R
330-PM250 YL - 18 200-PM105 BK - 18 619-PM213 GN - 14 3 CONN 21
441-PM38 OR - 18 308-PM124 YL - 18 606-PM86 GY - 18 5 PU/RD 367-PM11 BU
- 18 617-PM215 BR - 18 4
TO HEADLIGHT AS HARN
56a
447-PM156 PK - 18 308-PM132 YL - 18 611-PM85 PU - 14 6 WH LOW BEAM 419-PM253 YL - 18 143-PM99 BR - 18 618-PM217 YL - 18 5
CONN RL-C1
49a L R
450-PM33 YL - 18 308-PM247 YL - 18 537-PM230 GN - 18 7 PU/WH 518-PM120 OR - 16 976-PM98 OR - 18 D9 C9 B9 F9 606-PM50 GY - 18 6 (VOL 2 LOC I-6)
452-PM139 PU - 18 8 537-PM223 GN - 18 605-PM89 YL - 18 7
309-PM95 GY - 18 309-PM95 GY - 18 HIGH BEAM 568-PM80 GN - 18 A9 AA9 8

86

30
H2 503-PM177 BR - 16 310-PM93 PU - 18 310-PM93 PU - 18 RIDE CONTROL RLY
507-PM114 WH - 18 320-PM128 OR - 18 601-PM12 GY - 16 146-9439 BUCKET POS SW
521-PM226 YL - 18 PM-C83 WIPER 601-PM13 GY - 16 K5 F10 PV-C2 PV-C1 317-4920
564-PM224 GY - 16 324-PM19 BU - 18 1552273 601-PM14 GY - 16 CONN 20 3E3370 2228935

87A
ROADING LIGHTS

87

85
31b
568-PM80 GN - 18 500-PM203 BR - 16 1 BN/BU 614-PM26 PU - 18 D10 C10 B10
20A 103-PM96 RD - 14 TO PLATFORM HARN A R912-PV1 OR - 18 1
53b
603-PM237 PK - 16 502-PM34 OR - 16 2 BK/BU/WH 617-PM214 BR - 18 N939-PM107 GN - 18 A10 AA10 CONN PM-C39 B 762-PV2 YL - 18 2
53 RETURN TO DIG SW
607-PM235 PK - 16 330-PM29 YL - 18 501-PM179 GN - 16 3 BK/BU/YL 618-PM216 YL - 18 202-PM102 BK - 18 102-PM246 RD - 14 102-PM246 RD - 14 (VOL 1 LOC F-3) C
J PX-C1
608-PM236 GN - 16 330-PM64 YL - 18 590-PM192 GY - 18 720-PM130 PU - 18 206-1486
610-PM153 OR - 16 330-PM250 YL - 18 118-PM45 GY - 16
4
5
BK/BU/BN
BK/BU
15
WASHER
766-PM111 GN - 18 CONN 20 3E3370
53c
614-PM155 PU - 18 506-PM255 PU - 18 6 BK/YL 911-PM5 YL - 18 TO PLATFORM HARN A 143-PX1 BR - 18
614-PM225 PU - 18 367-PM11 BU - 18 367-PM11 BU - 18 976-PM98 OR - 18 CONN PM-C39 B 762-PX2 YL - 18
620-PM231 WH - 16 405-PM122 GY - 18 405-PM122 GY - 18 102-PM246 RD - 14 102-PM246 RD - 14 A305-PM151 YL - 18 112-PM10 PU - 10 112-PM10 PU - 10 (VOL 1 LOC F-3) C
627-PM206
630-PM233
YL - 18
GY - 16
406-PM27 PU - 18 406-PM27 PU - 18
104-PM197 RD - 18
E727-PM141
G763-PM257
BU - 18
PU - 18
112-PM20 PU - 10
146-PM36 GY - 10
112-PM20
146-PM36
PU - 10
GY - 10
RTD - ATCH RETURN TO DIG - ATCH
A305-PM151
E727-PM141
YL - 18
BU - 18
419-PM55 YL - 18 419-PM25 YL - 18
419-PM253 YL - 18 605-PM172 YL - 18
104-PM198
104-PM199
RD - 18
RD - 18
J881-PM57
J881-PM81
YL - 18
YL - 18
PM-C47
2757877
146-PM47 GY - 10 146-PM47 GY - 10 SINGLE TILT ONLY PARALLEL LIFT NON-EST ONLY
G981-PM142 PU - 16 606-PM171 GY - 18 104-PM200 RD - 18 J881-PM205 YL - 18
H771-PM145 BR - 18 420-PM169 OR - 18 420-PM169 OR - 18 161-PM103 RD - 16 104-PM201 RD - 18 N939-PM107 GN - 18
M719-PM183 GN - 18 159-PM100 BU - 16 N945-PM228 OR - 18 L2 L1
M721-PM184 WH - 18 432-PM168 PK - 18 614-PM173 PU - 18 105-PM18 RD - 18 105-PM18 RD - 18 P915-PM22 PK - 18 AIR SEAT FR FLOOD
CONN 20
F F
432-PM134 PK - 18 105-PM32 RD - 18 105-PM32 RD - 18 X750-PM23 OR - 18 180-PM238 GN - 14 20A 15A FUSES BUCKET POS SENSOR
432-PM259 PK - 18 8 1 3 4 17 18 105-PM60 RD - 16 105-PM60 RD - 16 X977-PM248 YL - 18 C1 D1 A1 AA1 10A 113-8490 PM-C39 PW-C2 PW-C1 3E-7843
H2 HAZARD SW 111-PM41 RD - 16 111-PM41 RD - 16 X977-PM249 YL - 18 F11 F1 1552267 3E3370 3E3370
15A 113-8491
439-PM70 YL - 18 439-PM70 YL - 18 306-7346 115-PM190 RD - 18 115-PM190 RD - 18 X977-PM251 YL - 18 158-PM245 BR - 16 143-PM68 BR - 18 A R912-PW1 OR - 18 A OR-18 + BATTERY
116-PM243 BR - 16 20A 113-8492
H2 441-PM38 OR - 18 441-PM38 OR - 18 116-PM243 BR - 16 762-PM16 YL - 18 B 762-PW2 YL - 18 B BU-18 SOLENOID
447-PM156 PK- 18 447-PM156 PK - 18 PM-C24 117-PM242 YL - 16 117-PM242 YL - 16 RR FLOOD FR FLOOD ATCH 200-PM94 BK - 18 C 200-PW3 BK - 18 C BK-18 GROUND
10 2 5 7 1387675 118-PM180 GY - 16 118-PM180 GY - 16 116-PM243 BR - 16 15A 15A
450-PM33 YL - 18 450-PM67 YL - 18 119-PM241 PK - 16 119-PM241 PK - 16 C2 D2 A2 AA2
450-PM185 YL - 18 202-PM174 BK - 18 123-PM2 WH - 18 123-PM2 WH - 18 F12 F2 RTD - ATCH
452-PM139 PU - 18 452-PM139 PU - 18
518-PM120 OR - 16
537-PM219 GN - 18
123-PM79
123-PM150
WH - 18
WH - 18
123-PM79
123-PM150
WH - 18
WH - 18
157-PM244 YL - 16
PARALLEL LIFT EST ONLY
500-PM203 BR - 16 500-PM203 BR - 16 123-PM143 WH - 18 123-PM143 WH - 18 RR FLOOD ATCH FR WIPER
501-PM179 GN - 16 501-PM179 GN - 16 124-PM227 GN - 18 124-PM227 GN - 18 117-PM242 YL - 16 15A 20A
502-PM34 OR - 16 502-PM34 OR - 16 133-PM84 OR - 16 133-PM84 OR - 16 C3 D3 A3 AA3 PM-C5 RTD SOLENOID
503-PM177 BR - 16 143-PM68 BR - 18 143-PM68 BR - 18 F13 F3 1552269 321-9976
H6 H6
143-PM99 BR - 18 143-PM99 BR - 18 118-PM180 GY - 16 762-PM16 YL - 18 1
419-PM25 YL - 18 143-PM138 BR - 14 143-PM138 BR - 14 200-PM7 BK - 18 2
614-RH66 PU - 0.75 506-PM252 PU -
18 102-PM246 RD - 14 202-PM165 BK - 18 144-PM187 GN - 16 144-PM187 GN - 16 RR WIPER AIR CON COMP
M936-RH93 BR - 0.75 506-PM116 PU - 18 105-PM18 RD - 18 157-PM244 YL - 16 157-PM244 YL - 16 119-PM241 PK - 16 20A 10A
STD FRONT WORK LAMP SW M937-RH69 GN - 0.75 PM-C27 506-PM255 PU - 18 105-PM32 RD - 18 1B 2B 158-PM245 BR - 16 158-PM245 BR - 16 C4 D4 A4 AA4
214-4697 3E3364 105-PM60 RD - 16 LH IND LAMP 159-PM100 BU - 16 159-PM100 BU - 16 F14 F4 PM-C46 PM-C4

PARK BRAKE
LEFT TURN
(4 LIGHT) 8 1 3 4 6 10 1 419-PM55 YL - 18 507-PM114 WH - 18 507-PM114 WH - 18 111-PM41 RD - 16 214-4717 161-PM103 RD - 16 161-PM103 RD - 16 124-PM227 GN - 18 1552272 3E3376
NOTE L NOTE: CONNECTOR 2 202-PM69 BK - 18 518-PM120 OR - 16 115-PM190 RD - 18 180-PM238 GN - 14 123-PM143 WH - 18 1 IF LOAD CHECK DISABLE IS INSTALLED,
NOT USED 116-PM243 BR - 16 IMP DISABLE MONITORING 202-PM119 BK - 18 2 265-PM158 BK - 18 REMOVE JUMPER AND CONNECT TO
PARK BRAKE SW PM-C19
521-PM226 YL - 18 521-PM226 YL - 18 117-PM242 YL - 16 1A 2A 200-PM94 BK - 18 200-PM94 BK - 18 143-PM138 BR - 14 20A 15A N939-PM137 GN - 18 3 LOAD CHECK DISABLE HARNESS CONN
154-5416 2055471
RH-C11 118-PM180 GY - 16 200-PM110 BK - 18 200-PM110 BK - 18 C5 D5 A5 AA5 265-PM66 BK - 18 4 LN-C2 (VOL 2 LOC G-7)
7 2 5 9 2285856 537-PM219 GN - 18 119-PM241 PK - 16 605-PM91 YL - 18 200-PM220 BK- 14 200-PM220 BK - 14 F15 F5

J764-RH65 BR - 0.75
537-PM223 GN - 18
537-PM230 GN - 18
123-PM2
123-PM79
WH - 18
WH - 18
308-PM75 YL - 18 200-PM240 BK - 14 133-PM84 OR - 16 CONN 19
202-RH67 BK - 0.75 105-RH51 RD - 1.00 105-RH51 RD - 1.00 105-RH64 RD - 1.00 123-PM150 WH - 18 TURN SIGNAL BEACON
105-RH60 RD - 0.75 105-RH60 RD - 0.75 CONN 11 PM-C35
1552267
552-PM162 WH - 18 123-PM143 WH - 18 200-PM7 BK - 18 159-PM100 BU - 16 10A 15A PM-C34
1552273
PM-C15
3E3382
STD REAR WORK LAMP SW 133-RH12 OR - 0.75 TO HVAC HARNESS 124-PM227 GN - 18 200-PM56 BK - 12 C6 D6 A6 AA6
214-4699 614-RH75 PU - 0.75 133-RH13 OR - 0.75 116-RH22 BR - 1.00 116-RH22 BR - 1.00 CONN AC-C7 A 124-PM227 GN - 18 564-PM224 GY - 16 133-PM84 OR - 16 202-PM164 BK - 18 200-PM104 BK - 18 F16 F6 105-PM32 RD - 18 1
(4 LIGHT) H771-RH91 BR - 0.75 202-RH2 BK - 0.75 117-RH23 YL - 1.00 117-RH23 YL - 1.00 (VOL 2 LOC C-7) B 614-PM225 PU - 18 143-PM68 BR - 18 202-PM43 BK - 18 200-PM9 BK - 18 144-PM187 GN - 16 202-PM113 BK - 18 2
IF MSS IS INSTALLED, REMOVE
NOTE L H771-RH18 BR - 0.75 202-RH8 BK - 0.75 C 521-PM226 YL - 18 568-PM80 GN - 18 568-PM80 GN - 18 143-PM99 BR - 18 200-PM46 BK - 18 308-PM117 YL - 18 3
JUMPER AND CONNECT TO MSS HARN
M719-RH85 GN - 0.75 119-RH40 PK - 1.00 590-PM192 GY - 18 590-PM192 GY - 18 143-PM138 BR - 14 1B 2B 200-PM221 BK - 18 200-PM105 BK - 18 265-PM66 BK - 18
307-RH56 OR - 0.75 FUEL PUMP 4 218-PM129 BK - 18 CONN MX-C1
M721-RH87 WH - 0.75 308-RH61 YL - 1.00 119-RH41 PK - 1.00 119-RH94 PK - 1.00 601-PM15 GY - 16 144-PM187 GN - 16 RH IND LAMP 200-PM108 BK - 18 15A 218-PM24 BK - 18 5 (VOL 2 LOC I-7)

RIGHT TURN
POWER SS SW

HI BEAM
309-RH72 GY - 0.75 157-PM244 YL - 16 214-4723 200-PM222 BK - 18 C7 D7 A7 AA7 200-PM110 BK - 18 6
261-5070 8 1 3 4 6 10 SIDE SHIFT LOCK SW 310-RH59 PU - 0.75 133-RH12 OR - 0.75 133-RH52 OR - 0.75 603-PM237 PK - 16 158-PM245 BR - 16 200-PM258 BK - 18 F7
MOM

MOM

NOTE W 214-4713 133-RH13 OR - 0.75 POWER PORT

178-7539
115-PM190 RD - 18 159-PM100 BU - 16 PM-C17 123-PM79 WH - 18 CONN 18
NOTE W H6 404-RH76 YL - 0.75 200-PM221 BK - 18 161-PM103 RD - 16 1A 2A 2055471 202-PM3 BK - 18 202-PM3 BK - 18
405-RH55 GY - 0.75 143-RH82 BR - 0.75 143-RH95 BR - 0.75 604-PM209 OR - 18 604-PM71 OR - 18 200-PM94 BK - 18 202-PM31 BK - 18 202-PM31 BK - 18 SPARE 1
RH-C8 420-RH79 OR - 0.75 143-RH96 BR - 0.75 604-PM72 OR - 18 200-PM110 BK - 18 611-PM49 PU - 18 202-PM61 BK - 18 202-PM61 BK - 18 10A

E SIDE SHIFT SOLENOID STATUS

7 2 5 9 2285856

R912-RH83 OR - 0.75
432-RH7
439-RH58
441-RH17
PK - 0.75
YL - 0.75
OR - 0.75
144-RH38
157-RH35
GN - 1.00
YL - 1.00
144-RH38 GN - 1.00
157-RH35 YL - 1.00
605-PM89
605-PM90
YL - 18
YL - 18
200-PM220
200-PM221
202-PM3
BK - 14
BK - 18
BK - 18
606-PM87 GY - 18 202-PM65
202-PM92
BK - 18
BK - 18
202-PM65
202-PM92
202-PM102
BK - 18
BK - 18
BK - 18
C8 D8 A8
F8
AA8
E
FUNCTION SIDE SHIFT LOCK SIDE SHIFT LEFT SIDE SHIFT RIGHT LOCKOUT 202-RH74 BK - 0.75 447-RH16 PK - 0.75 158-RH34 BR - 1.00 158-RH34 BR - 1.00 605-PM211 YL - 18 605-PM91 YL - 18 202-PM31 BK - 18
STATIONARY OFF OFF OFF OFF 450-RH57 YL - 0.75 H2 605-PM172 YL - 18 202-PM61 BK - 18 PM-C54 PM-C44 202-PM113 BK - 18 202-PM113 BK - 18 SPARE 2
452-RH84 PU - 0.75 200-RH19 BK - 0.75 200-RH99 BK - 0.75 202-PM65 BK - 18 1552272 3E3376 202-PM119 BK - 18 202-PM119 BK - 18 15A
SHIFT LEFT ENERGIZE ENERGIZE OFF ENERGIZE
614-RH33 PU - 0.75 568-RH80 GN - 0.75 200-RH24 BK - 0.75 200-RH73 BK - 0.75 606-PM50 GY - 18 202-PM92 BK - 18 143-PM157 BR - 18 1 143-PM54 BR - 18 IF AWS IS INSTALLED, 202-PM160 BK - 18 202-PM160 BK - 18 C9 D9 A9 AA9
SHIFT RIGHT ENERGIZE OFF ENERGIZE ENERGIZE 607-RH36 PK - 1.00 614-RH92 PU - 0.75 606-PM86 GY - 18 202-PM113 BK - 18 G795-PM135 OR - 18 2 REMOVE JUMPER AND CONNECT TO 202-PM178 BK - 18 202-PM178 BK - 18 F9
PWR BEYOND OFF OFF OFF ENERGIZE 620-RH37 WH - 1.00 E727-RH28 BU - 0.75 202-RH8 BK - 0.75 606-PM210 GY - 18 606-PM87 GY - 18 202-PM119 BK - 18 614-PM4 PU - 18 3 AWS HARNESS CONN 202-PM207 BK - 16 202-PM207 BK - 16
F420-RH86 GN - 0.75 202-RH31 BK - 0.75 606-PM171 GY- 18 202-PM160 BK - 18 200-PM1 BK - 18 4 WP-C2 (VOL 2 LOC B-12) 202-PM229 BK - 16 202-PM229 BK - 16
8 1 3 4 6 10 ATTCH FRONT WORK LAMP SW
214-4698
F443-RH98
G423-RH77
GN - 0.75
PK - 0.75
202-RH32
202-RH62
BK - 0.75
BK - 0.75 607-PM235 PK - 16
202-PM178
202-PM207
BK - 18
BK - 16
CONN 15 202-PM256 BK - 18 202-PM256
306-PM101
BK - 18
GN - 18
SPARE 3
20A
(8 LIGHT) - NOTE L G981-RH11 PU - 0.75 202-RH2 BK - 0.75 202-RH15 BK - 0.75 202-PM229 BK - 16 C10 D10 A10 AA10
202-RH3 BK - 0.75 608-PM236 GN - 16 202-PM256 BK - 18 307-PM118 OR - 18 307-PM118 OR - 18 F10
GAUGE CLUSTER RH-C1 202-RH6 BK - 0.75 307-PM118 OR - 18 307-PM163 OR - 18 307-PM163 OR - 18
339-3067 RH-C17 7 2 5 9 2285856 202-RH25 BK - 0.75 307-PM163 OR - 18 308-PM17 YL - 18 308-PM17 YL - 18
3402564 202-RH47 BK - 0.75 610-PM153 OR - 16
+12V BATTERY 1 105-RH60 RD - 0.75 157-RH35 YL - 1.00 202-RH71 BK - 0.75 610-PM115 OR - 14 308-PM17 YL - 18 308-PM37 YL - 18 308-PM37 YL - 18
GROUND 2 202-RH8 BK - 0.75 158-RH34 BR - 1.00 202-RH74 BK - 0.75 RH-C12 PM-C13 610-PM204 OR - 14 308-PM37 YL - 18 308-PM106 YL - 18 308-PM106 YL - 18
+12V KEY SWITCH 3 133-RH12 OR - 0.75 202-RH32 BK - 0.75 202-RH67 BK - 0.75 2722838 1673692 308-PM106 YL - 18 308-PM117 YL - 18 308-PM117 YL - 18
PM-C20
ALT "W" (TACHO) 4 450-RH57 YL - 0.75 116-RH22 BR - 1.00 202-RH89 BK - 0.75 105-RH64 RD - 1.00 1 105-PM62 RD - 16 611-PM49 PU - 18 308-PM117 YL - 18 308-PM124 YL - 18 308-PM124 YL - 18
1116795
ENG COOLANT TEMP 5 441-RH17 OR - 0.75 117-RH23 YL - 1.00 202-RH15 BK - 0.75 2 202-PM144 BK - 18 611-PM51 PU - 14 308-PM124 YL - 18 308-PM132 YL - 18 308-PM132 YL - 18
FUEL LEVEL 6 447-RH16 PK - 0.75 614-RH30 PU - 0.75 119-RH40 PK - 1.00 307-RH56 OR - 0.75 307-RH56 OR - 0.75 308-RH61 YL - 1.00 3 308-PM59 YL - 16 611-PM85 PU - 14 308-PM132 YL - 18 308-PM247 YL - 18 308-PM247 YL - 18 4 FLASHER
TORQUE CONV TEMP 7 452-RH84 PU - 0.75 603-RH39 PK - 1.00 119-RH41 PK - 1.00 308-RH61 YL - 1.00 308-RH61 YL - 1.00 200-RH73 BK - 0.75 4 200-PM97 BK - 18 308-PM247 YL - 18 309-PM95 GY - 18 309-PM95 GY - 18 200-PM222 BK - 18 1 GROUND 7T-4848
BRAKE PRESS./LEVEL 8 432-RH7 PK - 0.75 144-RH38 GN - 1.00 309-RH72 GY - 0.75 309-RH72 GY - 0.75 614-RH63 PU - 0.75 5 614-PM155 PU - 18 614-PM4 PU - 18 309-PM95 GY - 18 310-PM93 PU - 18 310-PM93 PU - 18 518-PM120 OR - 16 2 BATTERY
HYD OIL HI TEMP 9 404-RH76 YL - 0.75 8 1 3 4 6 10 BEACON SW 157-RH35 YL - 1.00 627-RH4 YL - 0.75 6 627-PM206 YL - 18 614-PM26 PU - 18 310-PM93 PU - 18 320-PM128 OR - 18 320-PM128 OR - 18 537-PM223 GN - 18 5 LAMP OUT
AESC 10 214-4693 158-RH34 BR - 1.00 310-RH53 PU - 0.75 143-RH95 BR - 0.75 7 143-PM140 BR - 18 614-PL155 PU-18 614-PM173 PU - 18 320-PM128 OR - 18 322-PM167 GY - 18 3
ALT "D+" 11 309-RH72 GY - 0.75 200-RH24 BK - 0.75 310-RH59 PU - 0.75 310-RH54 PU - 0.75 F420-RH86 GN - 0.75 8 406-PM27 PU - 18 614-PM225 PU - 18 614-PM218 PU - 18 330-PM64 YL - 18
ENG OIL LO PRESS. 12 405-RH55 GY - 0.75 202-RH3 BK - 0.75 158-RH34 BR - 1.00 9 158-PM245 BR - 16 330-PM250 YL - 18 324-PM19 BU - 18 324-PM19 BU - 18
PARK BRAKE ON 13 RH-C4 202-RH6 BK - 0.75 404-RH76 YL - 0.75 404-RH76 YL - 0.75 157-RH35 YL - 1.00 10 157-PM244 YL - 16 617-PM125 BR - 18 617-PM214 BR - 18 324-PM19 BU - 18 330-PM64 YL - 18 330-PM64 YL - 18
ACTION LAMP 14 F420-RH86 GN - 0.75 7 2 5 9 2285856 202-RH25 BK - 0.75 405-RH55 GY - 0.75 405-RH55 GY - 0.75 144-RH38 GN - 1.00 11 144-PM187 GN - 16 617-PM215 BR - 18 367-PM11 BU - 18 330-PM250 YL - 18 330-PM250 YL - 18 J881-PM205 YL - 18
START AID 15 310-RH59 PU - 0.75 202-RH31 BK - 0.75 420-RH79 OR - 0.75 420-RH79 OR - 0.75 116-RH22 BR - 1.00 12 116-PM243 BR - 16 405-PM122 GY - 18 367-PM11 BU - 18 367-PM11 BU - 18 308-PM247 YL - 18
AIR FILTER BLOCKED 16 420-RH79 OR - 0.75 144-RH38 GN - 1.00 202-RH32 BK - 0.75 432-RH7 PK - 0.75 432-RH7 PK - 0.75 117-RH23 YL - 1.00 13 117-PM242 YL - 16 618-PM149 YL - 18 618-PM216 YL - 18 406-PM27 PU - 18 405-PM122 GY - 18 405-PM122 GY - 18
WATER IN FUEL 17 439-RH58 YL - 0.75 202-RH31 BK - 0.75 202-RH47 BK - 0.75 439-RH58 YL - 0.75 439-RH58 YL - 0.75 447-RH16 PK - 0.75 14 447-PM156 PK - 18 618-PM217 YL - 18 419-PM253 YL - 18 406-PM27 PU - 18 406-PM27 PU - 18
HYD FILTER BYPASS 18 G423-RH77 PK - 0.75 202-RH62 BK - 0.75 441-RH17 OR - 0.75 441-RH17 OR - 0.75 J764-RH78 BR - 0.75 15 NOTE D 420-PM169 OR - 18 419-PM253 YL - 18 419-PM253 YL - 18 NEUTRALIZER RLY 5 4 2
STABILITY WARNING 19 F443-RH98 GN - 0.75 202-RH67 BK - 0.75 447-RH16 PK - 0.75 447-RH16 PK - 0.75 450-RH57 YL - 0.75 16 450-PM33 YL - 18 619-PM213 GN - 14 432-PM168 PK - 18 420-PM169 OR - 18 420-PM169 OR - 18 140-9378
HYD ECU FAULT 20 614-RH88 PU - 0.75 202-RH71 BK - 0.75 450-RH57 YL - 0.75 450-RH57 YL - 0.75 432-RH7 PK - 0.75 17 432-PM134 PK - 18 439-PM70 YL - 18 432-PM168 PK - 18 432-PM168 PK - 18 K12
BACK-LIGHTING 21 614-RH92 PU - 0.75 608-RH26 GN - 1.00 202-RH74 BK - 0.75 452-RH84 PU - 0.75 452-RH84 PU - 0.75 603-RH39 PK - 1.00 18 603-PM237 PK - 16 630-PM233 GY - 16 441-PM38 OR - 18 439-PM70 YL - 18 439-PM70 YL - 18
ACTION ALARM + 22 P789-RH1 PK - 0.75 630-RH27 GY - 1.00 202-RH89 BK - 0.75 503-RH43 BR - 1.00 503-RH43 BR - 1.00 630-RH27 GY - 1.00 19 630-PM233 GY - 16 447-PM156 PK - 18 441-PM38 OR - 18 441-PM38 OR - 18 1 3 PM-C48
AIR CON SHUT-OFF 23 569-RH9 PK - 0.75 310-RH53 PU - 0.75 507-RH42 WH - 0.75 507-RH42 WH - 0.75 119-RH94 PK - 1.00 20 119-PM239 PK - 16 720-PM130 PU - 18 450-PM67 YL - 18 447-PM156 PK - 18 447-PM156 PK - 18 2579257
PARK BRAKE IN GEAR 24 568-RH80 GN - 0.75 8 1 3 4 6 10 ATTACH REAR WORK LAMP SW 503-RH43 BR - 1.00 507-RH42 WH - 0.75 21 507-PM114 WH - 18 450-PM185 YL - 18 450-PM67 YL - 18 450-PM67 YL - 18 X750-PM23 OR - 18
NEUT LOCK IN GEAR 25 E727-RH28 BU - 0.75 214-4700 507-RH42 WH - 0.75 564-RH20 GY - 1.00 503-RH43 BR - 1.00 22 503-PM177 BR - 16 752-PM212 YL - 18 452-PM139 PU - 18 450-PM185 YL - 18 450-PM185 YL - 18 766-PM111 GN - 18
STAB RAISE IN GEAR 26 G981-RH11 PU - 0.75 (8 LIGHT) - NOTE L 564-RH20 GY - 1.00 564-RH21 GY - 0.75 564-RH44 GY - 1.00 564-RH44 GY - 1.00 23 564-PM224 GY - 16 506-PM116 PU - 18 452-PM139 PU - 18 452-PM139 PU - 18 202-PM61 BK - 18

D RH-C5
RH-C3
2285856
564-RH21
603-RH39
GY - 0.75
PK - 1.00
568-RH80
603-RH39
GN - 0.75
PK - 1.00
568-RH80
603-RH39
GN - 0.75
PK - 1.00
307-RH56
607-RH36
608-RH26
OR - 0.75
PK - 1.00
GN - 1.00
24
25
26
307-PM146
607-PM235
608-PM236
OR - 16
PK - 16
GN - 16
754-PM77 BU - 18 754-PM28 BU - 18
754-PM208 BU - 18
507-PM114
518-PM120
521-PM226
WH - 18
OR - 16
YL - 18
506-PM116
507-PM114
518-PM120
PU - 18
WH - 18
OR - 16
506-PM116
507-PM114
518-PM120
PU - 18
WH - 18
OR - 16
330-PM64 YL - 18

LOW SIDE CTRL RLY 10 9 7

D
7 2 5 9
TO AC SHUTOFF HARN 2458026 607-RH36 PK - 1.00 607-RH36 PK - 1.00 607-RH36 PK - 1.00 133-RH52 OR - 0.75 27 133-PM84 OR - 16 537-PM223 GN - 18 521-PM226 YL - 18 521-PM226 YL - 18 140-9378
CONN AR-C3 1 133-RH13 OR - 0.75 117-RH23 YL - 1.00 608-RH26 GN - 1.00 608-RH26 GN - 1.00 608-RH26 GN - 1.00 620-RH37 WH - 1.00 28 620-PM231 WH - 16 766-PM82 GN - 18 552-PM162 WH - 18 537-PM223 GN - 18 537-PM223 GN - 18 K13
(VOL 2 LOC F-6) 2 569-RH9 PK - 0.75 116-RH22 BR - 1.00 610-RH5 OR - 1.00 610-RH5 OR - 1.00 610-RH5 OR - 1.00 441-RH17 OR - 0.75 29 441-PM38 OR - 18 766-PM111 GN - 18 568-PM80 GN - 18 552-PM162 WH - 18 552-PM162 WH - 18
202-RH89 BK - 0.75 614-RH30 PU - 0.75 568-RH80 GN - 0.75 30 568-PM80 GN - 18 766-PM112 GN - 18 601-PM15 GY - 16 568-PM80 GN - 18 568-PM80 GN - 18 6 8
H6 614-RH33 PU - 0.75 614-RH48 PU - 0.75 H771-RH90 BR - 0.75 31 H771-PM145 BR - 18 766-PM175 GN - 18 605-PM89 YL - 18
CONN 1 614-RH48 PU - 0.75 614-RH49 PU - 0.75 606-PM50 GY - 18 601-PM12 GY - 16
614-RH49 PU - 0.75 614-RH49 PU - 0.75 614-RH66 PU - 0.75 614-RH63 PU - 0.75 CONN 10 911-PM5 YL - 18 611-PM51 PU - 14 601-PM15 GY - 16 601-PM13 GY - 16 J881-PM57 YL - 18
627-RH4 YL - 0.75 614-RH66 PU - 0.75 614-RH75 PU - 0.75 614-RH97 PU - 0.75 614-PM26 PU - 18 601-PM14 GY - 16 202-PM160 BK - 18
614-RH68 PU - 0.75 614-RH81 PU - 0.75 RH-C13 PM-C2 A305-PM151 YL - 18 A305-PM151 YL - 18 617-PM214 BR - 18
8 1 3 4 6 10 REAR FOG LAMP SW 614-RH75 PU - 0.75 614-RH88 PU - 0.75 2698225 3E5179 E727-PM141 BU - 18 E727-PM141 BU - 18 617-PM215 BR - 18 605-PM89 YL - 18 605-PM89 YL - 18 306-PM101 GN - 18
214-4721 614-RH81 PU - 0.75 614-RH92 PU - 0.75 310-RH54 PU - 0.75 1 310-PM93 PU - 18 F739-PM152 GN - 18 618-PM216 YL - 18 606-PM50 GY - 18 606-PM50 GY - 18 330-PM250 YL - 18
NOTE J 614-RH88 PU - 0.75 614-RH30 PU - 0.75 R912-RH70 OR - 0.75 2 NOTE D 618-PM217 YL - 18 611-PM51 PU - 14 611-PM51 PU - 14
620-RH37 WH - 1.00 614-RH33 PU - 0.75 309-RH72 GY - 0.75 3 309-PM95 GY - 18 G763-PM257 PU - 18 619-PM213 GN - 14 614-PM26 PU - 18 614-PM26 PU - 18
ACTION ALARM + P789-RH1 PK - 0.75 RH-C16 627-RH4 YL - 0.75 614-RH68 PU - 0.75 405-RH55 GY - 0.75 4 405-PM122 GY - 18 720-PM130 PU - 18 617-PM214 BR - 18 617-PM214 BR - 18 NEUTRAL START RLY 5 4 2
343-4355 - 202-RH2 BK - 0.75 7 2 5 9 2285856 630-RH27 GY - 1.00 452-RH84 PU - 0.75 5 452-PM139 PU - 18 G981-PM142 PU - 16 752-PM212 YL - 18 617-PM215 BR - 18 617-PM215 BR - 18 140-9378
A305-RH10 YL - 0.75 620-RH37 WH - 1.00 620-RH37 WH - 1.00 610-RH5 OR - 1.00 6 610-PM153 OR - 16 754-PM208 BU - 18 618-PM216 YL - 18 618-PM216 YL - 18 K14
610-RH5 OR - 1.00 H771-RH18 BR - 0.75 627-RH4 YL - 0.75 627-RH4 YL - 0.75 439-RH58 YL - 0.75 7 439-PM70 YL - 18 H771-PM145 BR - 18 766-PM82 GN - 18 618-PM217 YL - 18 618-PM217 YL - 18
202-RH6 BK - 0.75 H771-RH91 BR - 0.75 630-RH27 GY - 1.00 630-RH27 GY - 1.00 E918-RH46 GN - 0.75 8 NOTE D 766-PM111 GN - 18 619-PM213 GN - 14 619-PM213 GN - 14 1 3 PM-C49
J764-RH65 BR - 0.75 A305-RH10 YL - 0.75 A305-RH10 YL - 0.75 E917-RH45 WH - 0.75 9 NOTE D J881-PM121 YL - 18 J881-PM121 YL - 18 766-PM112 GN - 18 720-PM130 PU - 18 720-PM130 PU - 18 2579257
M719-RH85 GN - 0.75 E727-RH28 BU - 0.75 E727-RH28 BU - 0.75 420-RH79 OR - 0.75 10 420-PM169 OR - 18 J881-PM123 YL - 18 J881-PM123 YL - 18 911-PM5 YL - 18 752-PM212 YL - 18 752-PM212 YL - 18 307-PM163 OR - 18
614-RH48 PU - 0.75 M721-RH87 WH - 0.75 E917-RH45 WH - 0.75 E917-RH45 WH - 0.75 G981-RH11 PU - 0.75 11 G981-PM142 PU - 16 M719-PM183 GN - 18 A305-PM151 YL - 18 754-PM208 BU - 18 754-PM208 BU - 18 202-PM178 BK - 18
503-RH43 BR - 1.00 M936-RH93 BR - 0.75 E918-RH46 GN - 0.75 E918-RH46 GN - 0.75 12 E727-PM141 BU - 18 766-PM82 GN - 18 766-PM82 GN - 18 X977-PM251 YL - 18
119-RH40 PK - 1.00 M937-RH69 GN - 0.75 F420-RH86 GN - 0.75 F420-RH86 GN - 0.75 M721-PM184 WH - 18 F739-PM152 GN - 18 766-PM111 GN - 18 766-PM111 GN - 18 200-PM258 BK - 18
507-RH42 WH - 0.75 R912-RH83 OR - 0.75 F443-RH98 GN - 0.75 F443-RH98 GN - 0.75 CONN 9 G763-PM257 PU - 18 766-PM112 GN - 18 766-PM112 GN - 18 202-PM102 BK - 18
564-RH21 GY - 0.75 G423-RH77 PK - 0.75 G423-RH77 PK - 0.75 J881-PM121 YL - 18 911-PM5 YL - 18 911-PM5 YL - 18 202-PM207 BK - 16 FUEL LIFT PUMP RLY 10 9 7
G981-RH11 PU - 0.75 G981-RH11 PU - 0.75 RH-C15 PM-C42 N939-PM107 GN - 18 J881-PM123 YL - 18 976-PM98 OR - 18 202-PM229 BK - 16 140-9378
OFF RH-C10 8 1 3 4 6 10 REAR WIPER SW 2458025 3E3382 N939-PM136 GN - 18 N939-PM107 GN - 18 K15
R CONTROL GND
ON
1762946 214-4709 H771-RH18 BR - 0.75 G423-RH77 PK - 0.75 1 NOTE D N939-PM137 GN - 18 N939-PM136 GN - 18 A305-PM151 YL - 18 A305-PM151 YL - 18
H771-RH90 BR - 0.75
ST
YL-16 1 308-RH61 YL- 1.00 NOTE H H771-RH91 BR - 0.75 404-RH76 YL - 0.75 2 NOTE D N939-PM137 GN - 18 E727-PM141 BU - 18 E727-PM141 BU - 18 6 8 IDENT PART NO. CHG LOC NOTE DESCRIPTION
MOM

C
E727-RH28 BU - 0.75 E727-PM141 BU - 18 N945-PM228 OR - 18 N945-PM228 OR - 18 F739-PM152 GN - 18 F739-PM152 GN - 18
OFF
PU-16 2 3
S HARNESS AS.
ON
OR-16 3 307-RH56 OR- 0.75 RH-C7 J764-RH14 BR - 0.75 A305-RH10 YL - 0.75 4 A305-PM151 YL - 18 G763-PM257 PU - 18 G763-PM257 PU - 18 NOTE A
ST B AC 213-6055 04 SH 2 B-7 H HVAC - CONSOLE
BR-16 4 105-RH51 RD- 1.00 7 2 5 9 2285856 J764-RH65 BR - 0.75 J764-RH78 BR - 0.75 M719-RH85 GN - 0.75 5 M719-PM183 GN - 18 123-PM2 WH - 18
M721-RH87 WH - 0.75 6 M721-PM184 WH - 18 J881-PM121 YL - 18 J881-PM57 YL - 18 X977-PM249 YL - 18 AE 238-7492 03 SH 2 H-2 J HVAC AIR CONDITION - ENGINE
KEY SW 202-RH3 BK - 0.75 143-RH82 BR - 0.75 M719-RH85 GN - 0.75 M719-RH85 GN - 0.75 J881-PM123 YL - 18 J881-PM81 YL - 18
110-7887 119-RH41 PK - 1.00 200-RH19 BK - 0.75 M721-RH87 WH - 0.75 M721-RH87 WH - 0.75 CONN 8 J881-PM205 YL - 18 200-PM56 BK - 12
NOTE LOC NOTE DESCRIPTION AR 338-5731 02 SH 2 E-6 J AIR CONDITION SHUTOFF
564-RH20 GY - 1.00 E917-RH45 WH - 0.75 M936-RH93 BR - 0.75 M936-RH93 BR - 0.75 J881-PM154 YL - 18 200-PM220 BK - 14 PM-C23 EF 310-2333 04 SH 2 H-4 ENGINE
VARIOUS NOTE A: ASSEMBLE TERMINALS TO DESIGNATED STUD
202-RH47 BK - 0.75 M937-RH69 GN - 0.75 M937-RH69 GN - 0.75 RH-C14 200-PM234 BK - 14 1552269 EP 178-8465 02 SH 2 E-2 H FUEL SHUTOFF (TURBO ENGINE)
E918-RH46 GN - 0.75 1519278 200-PM240 BK - 14 X977-PM248 YL - 18 1 FUEL LIFT PUMP DIODE SH 2 A-9 NOTE B: THERMOSTAT FITTED TO MACHINES WITH AIR CON ONLY. LF 327-4172 03 SH 2 E-15 J REAR FOG LAMP & LICENSE PLATE
J764-RH14 BR - 0.75 R912-RH50 OR - 0.75 M936-RH93 BR - 0.75 1 PM-C14 307-PM118 OR - 18 2 189-3158
NOT CONNECTED 1552269 LOWER CAB GND LN 342-8600 01 SH 2 G-7 J LOAD CHECK DISABLE - PLATFORM

C C
614-RH68 PU - 0.75 R912-RH50 OR - 0.75 R912-RH83 OR - 0.75 R912-RH70 OR - 0.75 M937-RH69 GN - 0.75 2 NEUT LOCK NOTE D: NOT USED ON MECHANICAL MACHINE
VARIOUS LP 328-7020 03 SH 2 E-15 J LICENSE PLATE
310-RH53 PU - 0.75 ALARM DIODE 1 J881-PM154 YL - 18
CONN 7 189-3158 2 P915-PM22 PK - 18
SH 1 G-8 NOTE E: CLOSED WHEN BRAKE IS DEPRESSED MX 295-5893 01 SH 2 I-8 J MACHINE SECURITY SYSTEM
8 1 3 4 6 10 START AID SW NOTE A J881-PM81 YL - 18 MY 257-7214 03 SH 2 I-10 J MACHINE SECURITY SYSTEM CONTROL
214-4722 308-PM132 YL - 18
MOM

SH 1 A-13 NOTE F: CONNECT WIRE AS. FROM PIN 2 TO 3 PE 263-9493 01 SH 2 D-13 J POWER SIDE SHIFT
RH-C18 ON CONNECTOR RH-C6.
N939-PM107 GN - 18 N939-PM107 GN - 18 PM 340-3214 02 SH 1 I-3 PLATFORM
RH-C9 2610524 CONN 6 N939-PM136 GN - 18 N939-PM136 GN - 18 PARK BRAKE ALARM RLY 5 4 2
VARIOUS NOTE H: OPTIONAL - BASED ON MACHINE CONFIGURATION. PV 328-8594 02 SH 1 F-1 H,J,S RETURN TO DIG (PARALLEL LIFT, NON-EST)
7 2 5 9 2285856 143-RH96 BR - 0.75 1 TO STABILITY WARNING HARN N939-PM137 GN - 18 N939-PM137 GN - 18 140-9378
614-RH97 PU - 0.75 2 CONN TA-C2 N945-PM228 OR - 18 N945-PM228 OR - 18 K16 PW 246-8047 02 SH 1 E-2 H,J,S RETURN TO DIG (PARALLEL LIFT)
(VOL 2 LOC E-9) VARIOUS NOTE J: ATTACHMENT HARNESS PX 233-7977 03 SH 1 F-2 H,J RETURN TO DIG (SINGLE TILT)
200-RH24 BK - 0.75 F443-RH98 GN - 0.75 3 X750-PM23 OR - 18
202-RH62 BK - 0.75 200-RH99 BK - 0.75 4 1 3 PM-C50 RH 338-5723 03 SH 1 C-12 CONSOLE - SIDE
2579257 SH 2 G-7 NOTE K: WHEN LOADER LOCKS ARE INSTALLED, REMOVE JUMPER AND CONNECT
R912-RH50 OR - 0.75
PM-C46 TO LN-C2 RK 246-8038 02 SH 1 H-3 J RIDE CONTROL
E991-RH29 GY- 0.75 E917-RH45 WH - 0.75 X977-PM248 YL - 18 568-PM80 GN - 18
614-RH81 PU - 0.75 E918-RH46 GN - 0.75 X977-PM249 YL - 18 419-PM253 YL - 18 RL 213-6057 03 SH 2 I-7 ROADING LIGHT
VARIOUS NOTE L: STD FRONT WORK AND STD REAR WORK SWITCHES ARE FOR
A305-RH10 YL - 0.75 X977-PM251 YL - 18 202-PM256 BK - 18 RM 340-3212 02 SH 2 I-12 H,Y REAR END (434E MECH EST)
8 1 3 4 6 10 STANDARD FLOOD LAMP ARRANGEMENTS (4 LAMPS TOTAL).
NOTE F X977-PM254 YL - 18 P915-PM22 PK - 18 RT 327-2272 03 SH 2 F-12 H REAR END (NON-MECH EST)
8 1 3 4 6 10 ATCH FRONT WORK LAMP AND ATCH REAR WORK LAMP SWITCHES ARE
JUMPER WIRE FOR MACHINES WITH OPTIONAL ATTACHMENT FLOOD LAMPS (8 LAMPS TOTAL).
10 9 7 RW 311-1218 02 SH 2 E-10 H REAR WIPER
MOM

HORN SW NOTE: CONNECTOR 165-0312 NEUT LOCK ALARM RLY

214-4701 NOT USED 140-9378 TA 350-1101 01 SH 2 D-9 H,J OBJECT HANDLING - SIDE
SH 2 B-8 NOTE M: WHEN USING A CAB WITH HEATER ONLY, HEATER AC SW IS
RH-C6 K17 TC 349-1099 01 SH 2 D-6 H,J OBJECT HANDLING - REAR
SH 2 B-9 REPLACED WITH VENT SW.
RH-C2 7 2 5 9 2285856
TE 349-1098 01 SH 2 D-6 H,J OBJECT HANDLING - CAB
7 2 5 9 2285856 6 8 SH 2 A-9 NOTE N: NORMALLY CLOSED AT PROPER REFRIGERANT CHARGE
J764-RH14 BR - 0.75 TF 349-1100 01 SH 2 D-5 H,J OBJECT HANDLING - HOE
202-RH25 BK - 0.75 143-RH82 BR - 0.75 TP 340-3551 02 SH 2 F-11 ROOF
SH 1 G-7 NOTE P: FOR MACHINES WITHOUT LOAD CHECK.
202-RH71 BK - 0.75 200-RH19 BK - 0.75 E727-PM141 BU - 18
WA 340-0147 02 SH 2 A-10 H,Y AWS - AXLE
G763-PM257 PU - 18
SH 1 I-7 NOTE R: FOR ITALY MACHINES, ADD JUMPER AS. 8Y-7833 TO CONN PM-C21 WC 246-0568 02 SH 2 D-2 H FUEL SHUTOFF (N.A. ENGINE)
WE 311-2701 04 SH 2 A-14 H,Y AWS - GAUGE
SH 2 B-13 NOTE S: NOT AVAILABLE ON 422E
WP 340-5211 03 SH 2 A-14 H,Y AWS - PLATFORM
SH 1 H-4 NOTE T: FOR HVAC ATTACHMENT CONNECT 122-BU FROM
SIDE CONSOLE SH 2 A-7 HVAC HARNESS TO HVAC PRM MODULE SB STUD.
WR
WT
256-6803
295-5891
03
02
SH
SH
2
2
C-5
B-5
J
J
PRODUCT LINK - RADIO - PL121SR
PRODUCT LINK JUMPER
SH 1 D-14 NOTE W: FOR POWER SIDESHIFT OPTION REPLACE
SIDE SHIFT LOCK SW WITH POWER SS SW. CABLE AS.
AA 246-8053 02 SH 2 E-3 POS (BAT TO STARTER)
SH 1 H-7 NOTE X: FOR ITALY MACHINES, REPLACE AWD SWITCH WITH AWD ITALY SWITCH
CC 246-8058 02 SH 2 C-1 POS (STARTER TO ALTERNATOR)
VARIOUS NOTE Y: FOR 434E MECHANICAL EST MACHINES ONLY GG 213-6091 04 SH 2 E-3 H POS (HD) (428 ONLY)
HH 213-6092 03 SH 2 E-4 H NEG (HD) (428 ONLY)
SH 2 D-2 NOTE Z: CONNECTION SUPPLIED WITH ENGINE KK 228-5089 00 SH 2 E-4 NEG
LL 213-6089 07 SH 2 E-3 POWER DISTRIBUTION

B STRAP AS.
B
- 8X-9618 01 SH 2 D-4 STRAP-GROUND CAB TO FRAME
- 7Y-3883 02 SH 2 D-4 STRAP-GROUND ENGINE TO FRAME

WIRE GROUP COLOR DESCRIPTIONS

GROUND CIRCUIT
WIRES THAT HAVE SYSTEM VOLTAGE WHEN THE KEY SWITCH IS OFF
COLOR ABBREVIATIONS WIRES THAT HAVE SYSTEM VOLTAGE WHEN THE KEY SWITCH IS ON
SYMBOL DESCRIPTION STARTING CIRCUIT
ABBREV COLOR
START AID CIRCUIT
CIRCUIT CONNECTED RD RED TRANSMISSION CONTROL CIRCUIT

CIRCUIT NOT CONNECTED WH WHITE MONITOR CIRCUIT

CHASSIS / AWD CIRCUIT
ELECTRICAL CONNECTION TO OR ORANGE
MACHINE STRUCTURE MACHINE SECURITY CONTROL CIRCUIT
INTERNAL ELECTRICAL CONNECTION
YL YELLOW HEATER AND AIR CONDITIONER CIRCUIT
TO SURFACE OF COMPONENT PK PINK TURN SIGNAL / WIPER WASHER CIRCUIT
CAT DATA LINK
CONNECTOR BK BLACK
CAN DATA LINK (J1939)
H# CIRCUIT GROUPING DESIGNATION GY GRAY RS-232 DATA LINK

ATCH WIRE, CABLE, COMPONENT

PU PURPLE SIDE SHIFT CONTROL CIRCUIT
BR BROWN MACHINE CONTROL CIRCUIT
SPLICE
OTHER COLOR DESCRIPTIONS
A A
GN GREEN
BLADE, SPADE, RING OR SCREW
TERMINAL BU BLUE HIGHWAYS

THIS SCHEMATIC IS FOR THE 422E, 428E, and 434E

BACKHOE LOADER - E SERIES MECHANICAL (EAME)
VOLUME 1 of 2: CAB and CHASSIS
PART NUMBER: 329-0282, CHANGE: 00, VERSION: S
Components are shown installed on a fully operable machine with the key and engine off, transmission shifter
in neutral and with parking brake set.
Refer to the appropriate Service Manual for Troubleshooting, Specifications and Systems Operations.

14 13 12 11 10 9 8 7 6 5 4 3 2 1
 KENR8979-01
May 2011
Wire Description
Wire Wire Wire Wire
Description Description
Number Color Number Color
Power Circuits Lighting Circuits Continued

101 RD Bat (+) (Not Application Specific) 608 GN Flood Lamp - Rear

KENR8979-01 VOL 2 of 2
102 RD Head Lamp 610 OR Head Lamp - Basic
103 RD Power Batt (+) - Unswitched 611 PU Head Lamp - High
104 YL Auxilary Circuit 614 PU Park/Tail/Dash/Lamp
105 RD Key Switch 617 BR Tail/Position Lamp - Left (Road Package)
106 WH Auxilary Circuit 618 YL Tail/Position Lamp - Right (Road Package)

(Dimensions: 48 inches x 35 inches)

111 YL Rear Horn Relay 619 GN Head Lamp - Low
112 PU PRM Module #1 620 WH Flood Lamp - Front
115 RD ACC Power Port 627 YL Fog Lamp
116 BR Rear Flood Lamp 630 GY Flood Lamp Rear (ATCH)
117 YL Rear Flood Lamp (ATCH) Control Circuits

118 GY Front Wiper 702 OR AWD Switch to LH Brake Sw

119 PK Rear Wiper 708 YL XMSN Lock Switch
122 BU Heater/AC Switch 720 PU XMSN Brake Switch to AWD Relay
123 WH Quick Coupler 751 GN XMSN Speed Clutch Solenoid No. 1
124 GN A/C Compressor 752 YL XMSN Forward Low Solenoid
125 OR Product Link 754 BU XMSN Reverse Solenoid
126 PK Laser Grade Check 762 YL Bucket Positioner Solenoid Switch
133
136
OR
GN
Advisory Display
Differential Lock Relay
766
774
GN
YL
XMSN Disconnect Solenoid
Implement Disable Relay
422E, 428E and 434E
Backhoe Loader
143 BR Ride Control Relay 779 WH Coupler Engage Solenoid
144 GN Beacon 799 WH Sensor Power

Electrical System
146 GY PRM Module #1 C704 GY Shuttle Forward Sw
157 YL Front Flood Lamp (ATCH) C707 PK Shuttle Reverse Sw
158 BR Front Flood Lamp C720 BU XMSN Lock Switch
159 BU Aux Ckt C743 PK Parking Brake
161 RD Aux Ckt E701 PK Auto Ride Control Switch
422E: 428E: 434E:
180 GN Operator Seat E727 BU Diode - Parking Brake Relay MAW1-UP DPH1-UP SEF1-UP
Ground Circuits F711 GN CAN Link + (J1939)
200 BK Main Chassis F712 GY CAN Link - (J1939)
202 BK Ground Control F738 WH Active Ride Control Switch (N.C.)

36 Page,
207 BK Starter Diagnostic F739 GN Active Ride Control Switch (N.O.)
218 BK Start Relay F748 WH Ride Control Switch
225 BK Hydro Solenoid To Sensor G703 GN Load Check On
265 BK Electronic Pump Control G760 WH XMSN Speed Switch 2
A250 BK MSS Indicator (Return) G761 YL XMSN Speed Switch 3
Basic Machine Circuits G762 BR XMSN Speed Switch 4
304 WH Starter Relay No. 1 Output G763 PU XMSN Neutral Switch
306 GN Starter Relay Coil Or Key Switch G768 GN XMSN Control Speed Switch 1
307 OR Key Switch To VMIS Sensor Module G795 OR AWS Mode Switch To Rear Steer Switch
25 24 23
308 BK Main Power Relay Coil H705 BR Pump Relay
309 GY Alternator Regulator Terminal H707 YL Impl Cont Pump Torque Solenoid
310 PU Start Aid Switch To Start Aid Solenoid H730 BR Reverse Output - Shuttle Control
320 OR Horn Relay Coil To Switch H731 GY Forward Output - Shuttle Control
321 BR Backup Alarm Lamp Travel Alarm H764 GY Rear Steering Position Sensor
322 GY Warning Horn (Forward) H768 BR AWS Solenoid Ground 2
324 BU Differential Lock Solenoid H769 BR AWS Solenoid Ground 3
327 PK Shutdown Solenoid H770 BR AWS Solenoid Ground
331 OR Backup Alarm Relay Coil H771 BR Side Shift Lock Solenoid
Volume 2 of 2: Engine, Drivetrain and Attachments
333 GN Scraper Key Switch 'R' Terminal J764 BR Switch/Sensor Return (8v)
367 BU Warning Horn - Rear K764 WH Stick Extend Solenoid +
384 BU Relay To Glow Plugs K766 PK Stick Retract Solenoid + 2011 Caterpillar, All Rights Reserved Printed in U.S.A.
A305 YL Horn Power From Relay L740 BR Analog Sensor Return (+5V)
A
A346 BU MSS Start Relay Interrupt M719 GN Sideshift Left Switch
19 A347 GN Diode Assy - Start Relay Interrupt (MSS) M720 BU Sideshift Left Relay
B Monitoring Circuits M721 WH Sideshift Right Switch

3 403 GN Alternator (R) Terminal P789 PK Alarm Horn Output

28
32 27 404 YL Opr Mon Hydraulic Oil Temperature R762 GY Pattern Change Solenoid On
8 405 GY Opr Mon Oil Pressure (Low) R763 BU Pattern Change Solenoid Return
20 22
33 406 PU Opr Mon Coolant Temp U763 BU Circle Drive Control (Signal)

1
18
420 OR Opr Mon Fuel Filter/Low Accum Pressure X750 OR Fwd/Rev Solenoid Return From Controller Harness And Wire Electrical Schematic Symbols
9 432 PK Opr Mon Brake Pressure (Oil) 852 GN Continuous Flow Sw - NO to Ground
439 YL Water In Fuel Sensor 892 BR VMIS Start Mod Right (-) Port/CDL (-) Symbols
6 26 30 441 OR Engine Coolant Temp Gage 893 GN VMIS Start Mod Right (+) Port/CDL (+)
18 442 GY Hydraulic System Temperature Gage A884 WH AWS Diode to Differential Lock Relay
34 11 447 PK Fuel Level Gage E803 YL Right Ind Steer Solenoid T

12 7 21 Circuit Breaker
37 450 YL Tach Sender (+) E804 BU Left Ind Steer Solenoid
Pressure Temperature Level Flow
Symbol Symbol Symbol Symbol Symbol
5 452 PU Torque Converter E885 OR AWS Parity Signal
E455 BR Hydraulic Oil Filter F846 PU MSS Indicator LED Driver #1 (Red)
Symbols and Definitions
E479 YL Overload Warning Press Switch G848 GN MSS Indicator LED Driver #2
4 Fuse: A component in an electrical circuit that will open the circuit if too much current flows
F420 GN Warning Lamp (General) X800 OR +8V Sensor Power
through it.
F443 GN Stability Warning Press Sw Out 900 PU XMSN Shift Sol No. 5 Or 4
F444 PU Stability Warning Sw to Press Sw 902 BR XMSN Shift Sol No. 7 Switch (Normally Open): A switch that will close at a specified point (temp, press, etc.). The
G423 PK High Pressure Implement Filter - Rear 903 GY XMSN Shift Sol No. 8 circle indicates that the component has screw terminals and a wire can be disconnected from it.
Accessory Circuits 911 YL AWD Mode Switch Jumper
Switch (Normally Closed): A switch that will open at a specified point (temp, press, etc.).
500 BR Wiper - Front (Park) 922 BR XMSN Forward Solenoid Return No circle indicates that the wire cannot be disconnected from the component.
501 GN Wiper - Front (Low) 923 GY XMSN Reverse Solenoid Return
502 OR Wiper - Front (Hi) 973 BR CST Autoshift- Auto/Manual Switch 2 Ground (Wired): This indicates that the component is connected to a grounded wire. The
grounded wire is fastened to the machine.
503 BR Wiper - Rear (Park) 975 WH CST Autoshift- Sol Return
506 PU Washer - Front 976 OR Ride Control Solenoid #1 Ground (Case): This indicates that the component does not have a wire connected to ground.
507 WH Washer - Rear 977 YL CST Autoshift- Auto/Manual Switch #1 It is grounded by being fastened to the machine.
508 PU Radio Speaker - Left 985 GY Crab Steer Solenoid
Reed Switch: A switch whose contacts are controlled by a magnet. A magnet closes the
509 WH Radio Speaker - Left (Commom) E900 WH ECPC Trans Output Speed + contacts of a normally open reed switch; it opens the contacts of a normally closed reed switch.
511 BR Radio Speaker - Right E901 GN ECPC Trans Output Speed -
512 GN Radio Speaker - Right (Common) E917 WH Implement Lockout Switch To Ground (N.O.) Sender: A component that is used with a temperature or pressure gauge. The sender
measures the temperature or pressure. Its resistance changes to give an indication to
513 OR A/C Compressor/Refrigerant Pressure Sw. E918 GN Implement Lockout Switch To Ground (N.C.) T
the gauge of the temperature or pressure.
515 GY Blower Motor (HI) E991 GY Multi-Function Output #3
516 GN Blower Motor (MEDIUM) G962 OR Implement Lockout Solenoid / Diode Relay (Magnetic Switch): A relay is an electrical component that is activated by electricity.
It has a coil that makes an electromagnet when current flows through it. The
517 BU Blower Motor (Low) G981 PU Travel Alarm Disable
electromagnet can open or close the switch part of the relay.
518 OR Hazard Flasher To Switch L998 OR Auxiliary Hydraulic Solenoid B
521 YL A/C Switch To Refrigerant Switch L999 GN Auxiliary Hydraulic Solenoid C Solenoid: A solenoid is an electrical component that is activated by electricity. It has a
522 WH A/C Clutch To Thermostat Switch M936 BR Flow Control Switch coil that makes an electromagnet when current flows through it. The electromagnet
can open or close a valve or move a piece of metal that can do work.
537 GN Turn Signal Switch To Flasher M937 GN Flow Control Prox Sw #1
552 WH Four Wheel Drive Solenoid M952 BU LH Joystick Magnetic Latch Solenoid: A magnetic latch solenoid is an electrical component that is
564 GY Rear Wiper Interrupt Switch To Wiper Sw. M965 GN RH Joystick activated by electricity and held latched by a permanent magnet. It has two coils (latch and unlatch)
that make electromagnet when current flows through them. It also has an internal switch that places
568 GN Park Brake Warning Buzzer M968 BU Coupler Switch Interconnect
the latch coil circuit open at the time the coil latches.
569 PK A/C Switch Jumper #2 M969 YL Coupler Switch Interconnect
33 578 BU Auxiliary Washer N939 GN Ride Control Solenoid #2 (On) Harness and Wire Symbols
30 585 YL Aux Hydraulic - Open N945 OR AWD Sw to AWD Relay Wire, Cable, or Harness Harness Identification Letter(s):
20 586 BR Aux Hydraulic - Closed N957 PK RS-232 RXD - COMM #1 Assembly Identification: Includes (A, B, C, ..., AA, AB, AC, ...)
27 28 590 GY Intermittent Wiper N960 OR RS-232 TXD - COMM #1
Harness Identification Letters and
Harness Connector Serialization Code:
21 9
Harness Connector Serialization
The "C" stands for "Connector" and the
N970 YL RS-232 DTR - COMM #1 Codes (see sample).
C511 WH Relay Power number indicates which connector in the
AG-C4 L-C12 harness (C1, C2, C3, ...).
C568 WH Blower Motor N973 BR RS-232 DCD - COMM #1 L-C12
12 7 A 19 111-7898 3E-5179 3E-5179
25 24 E528 PU HVAC On/Off Switch To Blower Switch N979 GN RS-232 Signal Ground - COMM #1
22 E529 YL Blower Switch Jumper N997 WH PWM - Freq In #1
Part Number: for Connector Plug 1
18 Part Number: for Connector Receptacle
E540 PK Aux Hydraulic Interlock P993 OR Auxiliary Hydraulic Select 2
6 E543 WH Aux Hydraulic Return Solenoid - Close R912 OR Hydraulic Pedal Lock Solenoid
11 37 8 E544 GN Aux Hydraulic Return Solenoid - Open T904 BU RH Stabilizer Up - Switch To Solenoid
Plug Receptacle
Pin or Socket Number
1 5A
26 5
Lighting Circuits T907 GN LH Stabilizer Down - Switch To Solenoid
1 Deutsch connector: Typical representation
Component
32 601 GY Dash Lamp (Hi) T969 YL Aux Circuit 1 of a Deutsch connector. The plug contains all Fuse (5 Amps) 9X-1123 Part Number
18 34 2 sockets and the receptacle contains all pins.
23 603 PK Rotary Beacon T970 GY Stick Extend Solenoid (+)
325-AG135 PK-14
604 OR Stop Lamp T971 OR Aux Circuit 3 1 Sure-Seal connector: Typical representation Harness identification code:
B 605 YL Turn Lamp - Left T972 GN Stick Extend Solenoid (+) 2
of a Sure-Seal connector. The plug and receptacle This example indicates wire group 325, Wire Gauge
contain both pins and sockets. wire 135 in harness "AG". Wire Color
3 4 606 GY Turn Lamp - Right X977 YL Fuel Pump +V Supply
607 PK Flood Lamp - Front

Component Location Volume 2

Schematic Machine Schematic Machine
Component
Location Location
Component
Location Location Related Electrical Service Manuals
Alarm - Backup G-13, I-13 12 Relay - HVAC High Speed ATCH C-6 B Title Form Number
Alternator D-1 37 Relay - Immobilizer ATCH H-11 30 Electric Starting Motor: 143-0539 SENR3828
Battery - Std F-3 4 Relay - Start Aid D-2 4 Machine Troubleshooting: KENR8849
Battery - HD E-3 4 Resistor - Motor Speed (HVAC) ATCH B-8 B Engine Troubleshooting: KENR6900
Diode - Arc suppressor (HVAC) ATCH H-1 22 Sender - Fuel Level F-2 20
Diode - Arc supp 1 Load Chk Disable ATCH G-5 32 Sender - Temperature (Conv) F-2 26
Diode - Arc supp 2 Load Chk Disable ATCH G-5 33 Sender - Temperature (Coolant) G-2 22
MACHINE CONNECTOR & COMPONENT LOCATIONS Diode - Arc suppressor (Lockout) ATCH D-13 12 Sensor - AWS Position B-9 34
Diode - Arc suppressor (Reverse) I-2 21 Separator - Fuel Water H-2 30
Diode - Arc suppressor (Side Shift Lock) G-13, H-13 12 Solenoid - AC Compressor Clutch ATCH H-1 22
Diode - Arc suppressor (Side Shift 1) ATCH D-13 12 Solenoid - AWD F-2 21
Resistor, Sender and Solenoid Specifications
Diode - Arc suppressor (Side Shift 2) ATCH D-13 12 Solenoid - Cold Start ADV E-2 27
Part No. Component Description Resistance (Ohms)
Diode - Arc suppr (Side Shift Left) ATCH E-13 12 Solenoid - Differential Lock E-2 21
134-2540 Resistor: CAN Terminating 120
Diode - Arc suppr (Side Shift Right) ATCH D-13 12 Solenoid - Forward I-2 21
54C (130F) - 560 to 716
Diode As - Immobilizer ATCH I-11 30 Solenoid - Fuel Shutoff NA Eng E-2 27 244-3106 Sender: Coolant Temperature
110C (230F) - 72 to 82
Diode - Blocking (Load Chk Disable) ATCH G-7 6 Solenoid - Fuel Shutoff Turbo E-2 27
54C (130F) - 560 to 716
Gauge - AWS Position ATCH B-14 A Solenoid - Reverse I-2 21 4W-9972 Sender: Converter Temperature
110C (230F) - 72 to 82
Ground - Cab Roof G-8 23 Solenoid - Side Shift Lock G-14, I-14 12
Connector Location Volume 2 Ground - Engine H-3 5 Solenoid - Valve (LH Lock) ATCH H-5 33 303-2933 Sender: Fuel Level (Non-EST)
Empty - 246-252
Schematic Machine Full - 27-33
Connector Number Heater - Engine Block D-4 9 Solenoid - Valve (RH Lock) ATCH G-5 32
Location Location At room temperature unless otherwise noted.
Horn - Forward F-2 8 Switch - Air Filter G-2 28
CONN 1 F-6 B
Horn - RR G-13, H-13 12 Switch - AWS ATCH C-13 A
CONN 3 E-12 1
Module - PRM (Eng) C-1 4 Switch - Brake Fluid Level F-2 19
CONN 4 G-12, I-12 1
Motor - Blower HVAC ATCH C-8 B Switch - Blower Speed HVAC ATCH C-8 B
CONN 6 E-9 B
Motor - Fuel Lift Pump E-2 30 Switch - Crab Circle ATCH C-13 A
CONN 11 C-7 3
Motor - Front Washer G-2 19 Switch - Engine Oil Pressure G-2 30
CONN 12 G-10 3
Motor - Front Wiper G-8 24 Switch - Heater AC ATCH C-8 B
CONN 13 F-10 3
Motor - Rear Washer G-2 19 Switch - Pressure (AC Refrig) ATCH H-1 22
CONN 15 B-12 6
Motor - Rear Wiper E-10 25 Switch - Pressure (Boosted Brake) H-12 18
CONN 18 I-7 6 Off Machine Switch Specification
CONN 19 G-7 6 Motor - Starter C-3 11 Switch - Pressure (Engine Oil) G-2 30
Part No. Function Actuate Deactuate Contact Position
CONN 21 I-6 6 Plugs - Glow D-1 27 Switch - Pressure (Float Detent) ATCH G-5 B
3000 kPa MAX @ -40 C 2387 .345 kPa @ -40 C
Reader - Touchkey ATCH H-7 B Switch - Pressure (Stability) ATCH E-5 12 311-7711 Boosted Brake Pressure Normally Closed
CONN 24 H-4 7 (435.1 psi) to +121 C (346 0.05 psi) to +121 C
CONN 26 C-5 6 Relay - AC Shutoff ATCH E-5 B Switch - Stability Warning ATCH E-7 B
CONN 27 B-13 A Relay - Crank Interrupt ATCH I-7 B Switch - Thermostat HVAC ATCH B-8 B
CONN 28 F-13 12 Relay - Dead Engine Lower Comand ATCH F-5 6 Switch - Vent HVAC ATCH C-7 B
CONN 29 C-10 18 Relay - Dead Engine Lower Enable ATCH G-5 6 Valve As - AWS ATCH C-9 34
CONN 30 I-9 6 Valve As - Immobilizer ATCH I-11 30
CONN 33 E-10 25 Machine locations are repeated for components located close together.
CONN 34 C-7, E-6 B A = Located inside cab.
CONN 35 E-6 B B = Located inside right console.
CONN 36 E-6 B
CONN 37 E-5 12
The connectors shown in this chart are for harness to harness connectors.
Connectors that join a harness to a component are generally located at or near
the component. See the Component Location Chart.
 14 13 12 11 10 9 8 7 6 5 4 3 2 1
KENR8979-01 VOL 2 of 2

J J
(Dimensions: 48 inches x 35 inches)

MY-C1
1552264 MX-C1
RM-C2 GND 202-MY12 BK - 18 3E3382
1552272 READER/LED RTN
1
2 A250-MY3 BK - 18 105-MX1 RD - 18 1
CONN 18
STOP YL 1 604-RM2 OR - 18 +12V BATT 3 105-MY4 RD - 18 202-MX2 BK - 18 2 TO PLATFORM HARN RL-C2
REAR LH STT LAMP 1552273
I I
TURN OR 2 605-RM3 YL - 18 +12V KEY SW 4 308-MY10 YL - 18 308-MX5 YL - 18 3 CONN PM-C34
336-9096 TURN EF-C2
GND GY 3 200-RM4 BK - 18 START RLY OUT 5 A346-MY13 BU - 18 105-MY4 RD - 18 105-MY4 RD - 18 265-MX20 BK - 18 4 (VOL 1 LOC E-3) 605-RL9 YL - 18 1 BU
TAIL BK 4 617-RM1 BR - 18 START RLY RTN 6 200-MY7 BK - 18 200-MY7 BK - 18 105-MX1 RD - 18 105-MX1 RD - 18 218-MX3 BK - 18 5 200-RL1 BK - 16 2 BK 1552269
POSN FWD SOL
ON LED 7 G848-MY8 GN - 18 200-MX4 BK - 18 200-MX4 BK - 18 200-MX4 BK - 18 6 617-RL7 BR - 18 3 BR 752-EF29 YL - 18 1
200-RM4 BK - 18 200-RM11 BK - 14 CODE 8 F846-MY9 PU - 18 202-MY12 BK - 18 202-MY11 BK - 18 611-RL11 PU - 14 4 RD X750-EF25 OR - 18 2 324-2578
IMMOBILISER VALVE.AS 202-MY16 BK - 18 CONN 30 202-MX22 BK - 18 202-MX2 BK - 18 5
HIGH
202-MX21 BK - 18 LOW
200-RM14 BK - 18 MY-C2 MX-C2 200-RL3 BK - 16 200-RL1 BK - 16 619-RL10 GN - 14 6 GN
257-7211
200-RM25 BK - 18 225-MY17 BK - 18 225-MY17 BK - 18 3E3388 1552264 200-RL2 BK - 16
BACKUP ALARM + 754-RM22 BU - 18 200-RM10 BK - 18 202-MY11 BK - 18 1 202-MX22 BK - 18 218-MX3 BK - 18 RL-C1
170-0950 - 200-RM17 BK - 18 200-RM17 BK - 18 RM-C8 308-MY10 YL - 18 308-MY5 YL - 18 A250-MY3 BK - 18 2 A250-MX6 BK - 18 MX-C4 3E3388 605-RL9 YL - 18 605-RL9 YL - 18 LH HEADLIGHT AS. EF-C3
200-RM18 BK - 18 3E5179 308-MY15 YL - 18 105-MY4 RD - 18 3 105-MX1 RD - 18 265-MX20 BK - 18 1195094 1 611-RL12 PU - 14 606-RL8 GY - 18 606-RL8 GY - 18 RH DIP 195-0190 1552269
200-RM31 BK - 18 617-RM12
367-RM48
BR - 18
BU - 18
1
MY-C4 333-MY1 GN - 18 333-MY2 GN - 18
308-MY5 YL - 18
GN - 18
4 308-MX5
A347-MX11
YL - 18
GN - 18 308-MX5 YL - 18 308-MX5 YL - 18
218-MX3 BK - 18
A347-MX11 GN - 18
1
86 +
30
CONN 21 2
3
200-RL3
619-RL13
BK - 16
GN - 14 611-RL12 PU - 14 611-RL4 PU - 14
LH DIP 195-0192 X752-EF18 GY - 18
X750-EF34 OR - 18
1 REV SOL
324-2578
2 A347-MY6 5 5 2
RM-C10 367-RM48 BU - 18 367-RM48 BU - 18 604-RM13 OR - 18 1552272 333-MY14 GN - 18 BK - 18 200-MX4 BK - 18 A250-MX6 BK - 18 A250-MX6 BK - 18 202-MX21 BK - 18 TO PLATFORM HARN 4 617-RL7 BR - 18 611-RL11 PU - 14
3 200-MY7 6 2
1552269 605-RM3 YL - 18 A347-MY6 GN - 18 GN - 18 G848-MX7 GN - 18 A347-MX11 GN - 18 A347-MX11 GN - 18 265-MX20 BK - 18
85 - CONN PM-C1 5 618-RL6 YL - 18
4 1 G848-MY8 7 4
SIDE SHIFT LOCK BK-18 1 H771-RM19 BR - 18 604-RM2 OR - 18 604-RM13 OR - 18 606-RM9 GY - 18 5 CONN 4 DIODE AS 2 333-MY1 GN - 18 A250-MY3 BK - 18 A250-MY3 BK - 18 F846-MY9 PU - 18 8 F846-MX8 PU - 18 F846-MX8 PU - 18 F846-MX8 PU - 18 3
87
87A
(VOL 1 LOC G-3) 6 606-RL8 GY - 18 617-RL7 BR - 18 617-RL7 BR - 18 RL-C3
257-0478 BK-18 2 200-RM31 BK - 18 604-RM8 OR - 18 618-RM7 YL - 18 6 TO PLATF HARN 200-1898 3 225-MY17 BK - 18 A346-MY13 BU - 18 G848-MX7 GN - 18 G848-MX7 GN - 18 7 605-RL9 YL - 18 618-RL6 YL - 18 618-RL6 YL - 18 1552273
CRANK INTERRUPT RLY TURN EF-C13
627-RM28 YL - 18 7 CONN PM-C16 4 200-MY7 BK - 18 8 606-RL8 GY - 18 1 BU
605-RM3 YL - 18 605-RM3 YL - 18 754-RM22 BU - 18 8 (VOL 1 LOC H-12) A347-MY6 GN - 18 A347-MY6 GN - 18 115-1615 619-RL13 GN - 14 619-RL5 GN - 14 200-RL2 BK - 16 2 BK 1552269
POSN REV SOL DIODE
606-RM9 GY - 18 606-RM9 GY - 18 200-RM11 BK - 14 9 F846-MY9 PU - 18 F846-MY9 PU - 18 619-RL10 GN - 14 618-RL6 YL - 18 3 BR 123-EF62 WH - 18 X752-EF18 GY - 18 1
RM-C1 432-RM15 PK - 18 10 G848-MY8 GN - 18 G848-MY8 GN - 18 611-RL4 PU - 14 4 RD 754-EF42 BU - 18 2 189-3158
1552269 617-RM1 BR - 18 617-RM12 BR - 18 202-RM29 BK - 18 11 MX-C3 5
HIGH 123-EF10 WH - 18
SS LOCK SUPPR 1552267 LOW
1 H771-RM16 BR - 18 617-RM5 BR - 18 H771-RM24 BR - 18 12 619-RL5 GN - 14 6 GN 123-EF23 WH - 18
189-3158 2 200-RM18 BK - 18 MY-C5 F846-MX8 PU - 18 A CODE 123-EF28 WH - 18
36 Page,

618-RM7 YL - 18 618-RM7 YL - 18 2305008 MY-C3 A250-MX6 BK - 18 B COMMON EF-C26 123-EF52 WH - 18

1552269 1673693 AE-C3 A/C REFRIGERANT PRESS
627-RM28 YL - 18 627-RM28 YL - 18 BATTERY 1 308-MY15 YL - 18 TO FUEL SHUTOFF SOL G848-MX7 GN - 18 C LED RH HEADLIGHT AS. 123-EF53 WH - 18
754-RM22 BU - 18 754-RM22 BU - 18 GND 202-MY16 BK - 18 CONN EP-C1 RH DIP 195-0189 123-EF62 WH - 18 1684999 236-6923
2 333-MY2 GN - 18 1
TOUCHKEY READER
1
RM-C9 INPUT SIG 3 A346-MY13 BU - 18 225-MY17 BK - 18 2 (VOL 2 LOC E-2) LH DIP 195-0191 2 202-EF66 BK - 18 200-EF46 BK - 14 521-AE4 YL - 18 A
1552269 257-7212
H771-RM16 BR - 18 OUTPUT SIG 4 333-MY14 GN - 18 3 322-EF26 GY - 18 513-AE3 OR - 18 B
RR HORN 1 367-RM48 BU - 18 H771-RM19 BR - 18 H771-RM24 BR - 18 4 441-EF19 OR - 18 200-EF6 BK - 18
IMMOBILISER RELAY
164-9425 2 200-RM25 BK - 18 5 452-EF1 PU - 18 200-EF30 BK - 18
276-5450
TO 6 447-EF22 PK - 18 200-EF2 BK - 18
PLATFORM 7 521-EF14 YL - 18 200-EF3 BK - 18

RM-C4
IMMOBILISER SYSTEM - ATCH HEADLIGHTS HARN 8
9
552-EF17
754-EF42
WH - 18
BU - 18
200-EF5
200-EF33
BK - 18
BK - 18
AE-C2
1552269
CONN
1552272 202-RM29 BK - 18 PM-C3 10 752-EF29 YL - 18 200-EF41 BK - 18 513-AE5 OR - 18 1 BK-14
STOP YL 1 604-RM8 OR - 18 432-RM15 PK - 18 (VOL 1 11 506-EF27 PU - 18 200-EF58 BK - 18 200-AE6 BK - 18 2 BK-14
REAR RH STT LAMP TURN OR 2 606-RM9 GY - 18 LOC 12 507-EF20 WH - 18
336-9096 GND GY 3 200-RM10 BK - 18 I-3) 13 306-EF12 GN - 18 AC COMPRESSOR CLUTCH
TAIL BK 4 618-RM7 YL - 18 14 229-2212
15 405-EF39 GY - 18

H H
RM-C18 16 218-EF63 BK - 18 EF-C15 AE-C4 AE-C1

RM-C5
1552267 CONN 24 17 406-EF37 PU - 18 200-EF46 BK - 14 1552269 3E3364 1552269
HVAC SUPPR
432-RM15 PK - 18 A BK-18 18 521-EF14 YL - 18 1 521-AE4 YL - 18 513-AE1 OR - 18 1
1552267 B RD-18 19 439-EF16 YL - 18 200-EF41 BK - 18 2 200-AE7 BK - 18 200-AE2 BK - 18 2 189-3158
ENGINE GND
TO REAR FOG & LICENSE PLATE HARN A 627-RM28 YL - 18 202-RM29 BK - 18 C BU-18 20
CONN LF-C1 B 617-RM5 BR - 18 BOOSTED BRAKE PRESS SW
21 450-EF38 YL - 18
(SH 2 LOC E-14)
OR
C 200-RM14 BK - 18
311-7711
22
23
432-EF65 PK - 16
324-EF36 BU - 18 NOTE A
HVAC - ATCH
TO LICENSE PLATE HARN 24
CONN LP-C2 25 X750-EF31 OR - 18 EF-C16
(SH 2 LOC E-14) LN-C1 26 202-EF66 BK - 18 1552267
LH BEACON SKT 1552269 27 202-EF4 BK - 18 123-EF52 WH - 18 A PK-18 BATTERY FUEL WATER SEPARATOR
TP-C16 9R-7941 123-LN2 WH - 18 1 RD-18 28 420-EF60 OR - 18 202-EF43 BK - 18 202-EF44 BK - 18 B BK-18 GROUND 193-0618
1237615 G703-LN9 GN - 18 2 BR-18 29 310-EF15 PU - 18 202-EF48 BK - 16 439-EF16 YL - 18 C YL-18 LAMP
REAR END - MECH EST 603-TP48 PK - 18
200-TP24 BK - 18
1
LH BEACON.
128-6985 LH LOCK VALVE SOL
30
31
309-EF21
X977-EF8
GY - 18
YL - 18
202-EF7
202-EF13
BK - 18
BK - 18
2
NOTE H 123-LN17 WH - 18 123-LN2 WH - 18 262-7081 202-EF44 BK - 18
123-LN4 WH - 18 123-LN6 WH - 18 202-EF59 BK - 18
TP-C3 EF-C24
1552269 123-LN15 WH - 18 LN-C6 218-EF63 BK - 18 218-EF63 BK - 18 1237615
TP-C6 1552269 1
REAR LH FLOOD ATCH WH-18 1 630-TP15 GY - 18 123-LN3 WH - 18 306-EF12 GN - 18 306-EF12 GN - 18 506-EF27 PU - 18 FRONT WASHER MOTOR
214-2969 BK-18 2 200-TP11 BK - 18 1552269 123-LN25 WH - 18 123-LN15 WH - 18 1 RD-18 309-EF21 GY - 18 309-EF21 GY - 18 200-EF5 BK - 18 MOTOR 6T-1375
2
200-TP8 BK - 18 200-TP9 BK - 18 607-TP6 PK - 18 1 BK-18 FRONT LH FLOOD STD G703-LN10 GN - 18 2 BR-18 310-EF15 PU - 18 310-EF15 PU - 18
TP-C2 200-TP11 BK - 18 200-TP22 BK - 18 200-TP9 BK - 18 2 BK-18 214-2968 202-LN19 BK - 18 322-EF26 GY - 18 322-EF26 GY - 18
1552269 200-TP12 BK - 18 200-TP24 BK - 18 202-LN7 BK - 18 202-LN20 BK - 14 RH LOCK VALVE SOL 324-EF36 BU - 18 324-EF36 BU - 18
REAR LH FLOOD STD WH-18 1 608-TP2 GN - 18 200-TP27 BK - 12 TP-C7 202-LN21 BK - 12 262-7081 405-EF39 GY - 18 405-EF39 GY - 18
214-2968 BK-18 2 200-TP8 BK - 18 1552269 406-EF37 PU - 18 406-EF37 PU - 18 EF-C6
RT-C2 200-TP7 BK - 18 620-TP20 WH - 18 1 BK-18 FRONT LH FLOOD ATCH LN-C2 207-LN16 BK - 18 420-EF60 OR - 18 420-EF60 OR - 18 1237615
3E3376 LN-C7 1
1552272 200-TP26 BK - 12 200-TP14 BK - 18 2 BK-18 214-2969 207-LN13 BK - 18 207-LN22 BK - 18 432-EF65 PK - 16 432-EF65 PK - 16 507-EF20 WH - 18 REAR WASHER MOTOR

REAR LH STT LAMP

STOP YL 1 604-RT2 OR - 18 TP-C4
1552269
200-TP10 BK - 18 CONN 19 1 123-LN17 WH - 18 207-LN23 BK - 12 1552267 439-EF16 YL - 18 439-EF16 YL - 18 200-EF2 BK - 18 2
MOTOR 6T-1375
TURN OR 2 605-RT3 YL - 18 200-TP13 BK - 18 TO PLATFORM HARN 2 202-LN7 BK - 18 207-LN24 BK - 12 207-LN16 BK - 18 A BK-18 441-EF19 OR - 18 441-EF19 OR - 18
336-9096 GND GY 3 200-RT4 BK - 18 REAR RH FLOOD STD WH-18 1 608-TP3 GN - 18 200-TP14 BK - 18 TP-C8 3 N939-LN18 GN - 18 G703-LN5 GN - 18 B RD-18 447-EF22 PK - 18 447-EF22 PK - 18
1552269 CONN PM-C46
TAIL BK 4 617-RT1 BR - 18 214-2968 BK-18 2 200-TP7 BK - 18 (VOL 1 LOC E-3) 4 265-LN8 BK - 18 G703-LN5 GN - 18 202-LN20 BK - 14 C BU-18 450-EF38 YL - 18 450-EF38 YL - 18
608-TP2 GN - 18 620-TP19 WH - 18 1 BK-18 FRONT RH FLOOD ATCH G703-LN1 GN - 18 G703-LN10 GN - 18 FLOAT DETENT PRESS SW 452-EF1 PU - 18 452-EF1 PU - 18
TP-C5 608-TP3 GN - 18 200-TP13 BK - 18 2 BK-18 214-2969 NOTE K G703-LN12 GN - 18 506-EF27 PU - 18 506-EF27 PU - 18 EF-C23
1552269 194-2553 1166158 AIR FILTER SW
G703-LN26 GN - 12 507-EF20 WH - 18 507-EF20 WH - 18
REAR RH FLOOD ATCH WH-18 1 630-TP16 GY - 18 630-TP16 GY - 18 TP-C9 521-EF14 YL - 18 521-EF14 YL - 18 420-EF60 OR - 18 A 332-7333
214-2969 BK-18 2 200-TP12 BK - 18 630-TP15 GY - 18 1552269 G703-LN1 GN - 18 G703-LN9 GN - 18 552-EF17 WH - 18 552-EF17 WH - 18 202-EF59 BK - 18 B
BACKUP ALARM + 754-RT22 BU - 18 607-TP5 PK - 18 1 BK-18 FRONT RH FLOOD STD LN-C8 G703-LN11 GN - 18 LN-C4 LOAD CHECK DISABLE SUP1 752-EF29 YL - 18 752-EF29 YL - 18
170-0950 - 200-RT17 BK - 18 200-TP10 BK - 18 2 BK-18 214-2968 1552269 1552269 106-8704 754-EF42 BU - 18 754-EF42 BU - 18
200-RT11 BK - 14 BLOCKING DIODE 1 207-LN13 BK - 18 N939-LN18 GN - 18 N939-LN18 GN - 18 123-LN6 WH - 18 1

G RT-C10
200-RT4
200-RT14
200-RT25
BK - 18
BK - 18
BK - 18
CONN 12
TP-C1
105-TP28
118-TP29
RD - 18
GY - 14
105-TP28
118-TP29
RD - 18
GY - 14
608-TP3
608-TP2
GN - 18
GN - 18
106-8704 2 265-LN8 BK - 18 G703-LN11 GN - 18 2 X750-EF31 OR - 18 X750-EF25 OR - 18
X750-EF34 OR - 18 EF-C12
1552269
G
1552269 200-RT10 BK - 18 3E3382 119-TP30 PK - 14 119-TP30 PK - 14 X977-EF8 YL - 18 X977-EF8 YL - 18 441-EF19 OR - 18 1 COOLANT TEMP SENDER
SIDE SHIFT LOCK BK-18 1 H771-RT19 BR - 18 200-RT17 BK - 18 RT-C8 1 603-TP25 PK - 16 123-TP31 WH - 18 123-TP31 WH - 18 630-TP15 GY - 18 202-EF4 BK - 18 2
3E5179 244-3106
257-0478 BK-18 2 200-RT31 BK - 18 200-RT18 BK - 18 2 620-TP18 WH - 16 500-TP32 BR - 16 500-TP32 BR - 16 630-TP16 GY - 18 200-TP26 BK - 12 T
200-RT31 BK - 18 617-RT12 BR - 18 1 3 608-TP1 GN - 16 501-TP33 GN - 16 501-TP33 GN - 16 200-TP27 BK - 12 LN-C9 LOAD CHECK DISABLE SUP2
367-RT48 BU - 18 2 4 607-TP4 PK - 16 502-TP34 OR - 16 502-TP34 OR - 16 105-TP28 RD - 18 105-TP40 RD - 18 200-TP43 BK - 12 1552269 106-8704
367-RT48 BU - 18 367-RT48 BU - 18 604-RT13 OR - 18 3 5 105-TP28 RD - 18 503-TP35 BR - 16 503-TP35 BR - 16 105-TP38 RD - 16 123-LN3 WH - 18 1
RT-C1 GND CAB RF EF-C20
605-RT3 YL - 18 4 6 630-TP17 GY - 16 506-TP49 PU - 18 506-TP49 PU - 18 G703-LN12 GN - 18 2
1552269 604-RT2 OR - 18 604-RT13 OR - 18 606-RT9 GY - 18 5 CONN 4 564-TP36 GY - 16 564-TP36 GY - 16 118-TP29 GY - 14 118-TP29 GY - 14 1552269
SS LOCK SUPPR 1 H771-RT16 BR - 18 604-RT8 OR - 18 618-RT7 YL - 18 6 TO PLATF HARN TO PLATFORM HARN 590-TP23 GY - 16 590-TP23 GY - 16 119-TP30 PK - 14 406-EF37 PU - 18 1 NOT CONNECTED
189-3158 2 200-RT18 BK - 18 627-RT28 YL - 18 7 CONN PM-C16 CONN PM-C22 NOTE A 202-EF43 BK - 18 2
605-RT3 YL - 18 605-RT3 YL - 18 754-RT22 BU - 18 8 (VOL 1 LOC H-12) (VOL 1 LOC I-12) 603-TP25 PK - 16 603-TP21 PK - 18 123-TP31 WH - 18 123-TP31 WH - 18
606-RT9 GY - 18 606-RT9 GY - 18 200-RT11 BK - 14 9 603-TP48 PK - 18
10 200-TP39 BK - 16 200-TP41 BK - 18 LN-C5
RT-C9 617-RT1 BR - 18 617-RT12 BR - 18 11 607-TP4 PK - 16 607-TP5 PK - 18 200-TP37 BK - 14 200-TP42 BK - 14 H FRONT WIPER 9X1054 EF-C5
1552269 TP-C12 30 1552269
617-RT5 BR - 18 H771-RT24 BR - 18 12 607-TP6 PK - 18 200-TP43 BK - 12 313-3752 202-LN21 BK - 12 1 DEAD ENGINE LOWER ENABLE RLY
RR HORN 3E5179 TP-C13 T 86 ENGINE OIL PRESSURE SW
1 367-RT48 BU - 18 L 123-LN25 WH - 18 5 115-1615 405-EF39 GY - 18 1
1552264 MOTOR
164-9425 2 200-RT25 BK - 18 618-RT7 YL - 18 618-RT7 YL - 18 1 119-TP30 PK - 14 608-TP1 GN - 16 608-TP2 GN - 18 500-TP32 BR - 16 500-TP32 BR - 16 207-LN22 BK - 18 2 202-EF13 BK - 18 2 237-4894
85
627-RT28 YL - 18 627-RT28 YL - 18 2 503-TP35 BR - 16 608-TP3 GN - 18 501-TP33 GN - 16 501-TP33 GN - 16 1 207-LN23 BK - 12 4
87
754-RT22 BU - 18 754-RT22 BU - 18 3 564-TP36 GY - 16 502-TP34 OR - 16 502-TP34 OR - 16 506-TP49 PU - 18 2 PU 3
87a
4 118-TP29 GY - 14 620-TP18 WH - 16 620-TP19 WH - 18 503-TP35 BR - 16 500-TP32 BR - 16 3 BR
RT-C4 H771-RT16 BR - 18 H771-RT24 BR - 18 5 123-TP31 WH - 18 620-TP20 WH - 18 118-TP29 GY - 14 4 GY EF-C10
1552272 H771-RT19 BR - 18 6 500-TP32 BR - 16 506-TP49 PU - 18 506-TP49 PU - 18 200-TP42 BK - 14 5 BK 1552269
STOP YL 1 604-RT8 OR - 18 7 501-TP33 GN - 16 630-TP17 GY - 16 630-TP15 GY - 18 564-TP36 GY - 16 501-TP33 GN - 16 6 GN 447-EF22 PK - 18 1 RD-18 FUEL LEVEL SENDER
REAR RH STT LAMP TURN OR 2 606-RT9 GY - 18 8 502-TP34 OR - 16 630-TP16 GY - 18 590-TP23 GY - 16 7 GY LN-C3 202-EF7 BK - 18 2 BK-18 303-2933
336-9096 GND GY 3 200-RT10 BK - 18 9 590-TP23 GY - 16 590-TP23 GY - 16 590-TP23 GY - 16 502-TP34 OR - 16 8 OR 9X1054
30
TAIL BK 4 618-RT7 YL - 18 10 506-TP49 PU - 18 603-TP48 PK - 18 603-TP48 PK - 18 207-LN24 BK - 12 1 DEAD ENGINE LOWER COMMAND RLY
86
11 603-TP21 PK - 18 603-TP21 PK - 18 N939-LN18 GN - 18 5 115-1615
12 607-TP6 PK - 18 607-TP6 PK - 18 202-LN19 BK - 18 2
85
607-TP5 PK - 18 607-TP5 PK - 18 G703-LN26 GN - 12 4
87
CONN 13 620-TP20
620-TP19
WH - 18
WH - 18
620-TP20
620-TP19
WH - 18
WH - 18 CABLE AS
ANTENNA
8E-1118
3
87a
452-EF1 PU - 18 CONV TEMP SNDR
TO PLATFORM HARN 8R-6111 4W-9972
T
CONN PM-C6 DOME LAMP 105-TP38 RD - 16
LF-C3 LF-C1 RT-C5
(VOL 1 LOC I-12) 084-4277 200-TP39 BK - 16 LOAD CHECK DISABLE - ATCH
2304011 3E3370 1552267 + LH SPKR EF-C19
1 627-LF5 YL - 18 627-LF5 YL - 18 A 627-RT28 YL - 18 - 262-9567 ANTENNA 1552269
2 200-LF2 BK - 18 B 617-RT5 BR - 18 A-C2 322-EF26 GY - 18 1 FORWARD HORN

F REAR FOG LAMP

200-LF1 BK - 18 C 200-RT14 BK - 18
A-C1
1728037
CBL-LL1 RD - 2
200-EF3 BK - 18 2 164-9425
F
262-4727 CONN 28 TP-C15
1552264 3E3388
TO PRM BUSS BAR
BLOCK SH 1 LOC I-4
509-TP44 WH - 18 1 WH/BK-18 14 LH SPKR - NOTE A
LF-C2 508-TP45 PU - 18 2 WH-18 13 LH SPKR + (TO POS TERM) CBL-LL1 RD - 2 EF-C18
1552269 200-TP41 BK - 18 3 BK-18 8 GROUND 7N9738
1 617-LF4 BR - 18 617-LF4 BR - 18 4 432-EF65 PK - 16 1 BK-16 BRAKE FLUID LEVEL SW
2 200-LF3 BK - 18 105-TP40 RD - 18 5 YL-18 7 +12V BATT NOTE A 202-EF48 BK - 16 2 BR-16 4E-8619
123-TP31 WH - 18 6 RD-18 4 +12V KEY (TO NEG TERM)
LIC LAMP. 512-TP46 GN - 18 7 GY/BK-18 12 RH SPKR - CBL-KK1 BK - 00 CBL-AA1 RD - 00
196-0030 511-TP47 BR - 18 8 GY-18 11 RH SPKR +

CBL-HH1 BK - 00 CBL-GG1 RD - 00 EF-C4 AWD SOL

REAR FOG & LICENSE PLATE HARNESS RADIO
200-5728
1552269
552-EF17 WH - 18 1
305-3423

LAMPS (ATCH) RW-C2 RW-C1 TP-C14

+
-
RH SPKR
262-9567 AR-C3
NEG POS
BATTERY STD
3T-5760
200-EF58 BK - 18 2
L
1552272 3E3376 1552272 CONN 1 3E3364
GND AR-C1
BK 1 200-RW1 BK - 14 1 200-TP37 BK - 14 RADIO TO SIDE CONSOLE HARN 1 133-AR1 339-5436- GXL
MOTOR 1116795
GN 2 503-RW2 BR - 16 2 503-TP35 BR - 16 262-2781 CONN RH-C5 2 569-AR2 339-5437- GXL
LP-C2 (VOL 1 LOC D-14) 30 EF-C22
T RD 3 564-RW3 GY - 16 3 564-TP36 GY - 16 C511-AR3 WH - 18 1 A/C SHUTOFF RLY DIFF LOCK SOL
LP-C3
1552269
3E3370
A
TO REAR END - STD HARN
CONN RT-C5
P
B+
YL 4 119-RW4 PK - 14 4 119-TP30 PK - 14 RADIO - ATCH 569-AR2 PK - 18
133-AR1 OR - 18
5
2
86
3E-9362 CBL-HH1 BK - 00 CBL-GG1 RD - 00 1552269
324-EF36 BU - 18 1
305-3423
AR-C2 85 NEG POS
617-LP8 BR - 18 (VOL 2 LOC F-13) BATTERY HD 200-EF33 BK - 18
1 B
CONN 33 3E3364
4
87
2
2 200-LP7 BK - 18 C OR
TO REAR END - MECH EST HARN REAR WIPER
TP-C10
RH BEACON SOCKET
9R-7941
CONN 34 1 C511-AR3 339-5440- GXL
521-AR4 YL - 18 3
87a
3T-5760

CONN RM-C5 315-1318 1237615 TO AIR CON HARN

LIC LAMP 2 521-AR4 339-5441- GXL
196-0030 (VOL 2 LOC H-13) 603-TP21 PK - 18
200-TP22 BK - 18
1
RH BEACON
128-6985
CONN AC-C10
(VOL 2 LOC C-7)
NOTE A
BATTERY EF-C17 EP-C1 EP-C2
2 1552269 3E3364 1761477
(TO FRAME GROUND)
LICENSE PLATE LAMP ONLY REAR END - STD REAR WIPER CAB ROOF AIR CONDITIONER SHUTOFF - ATCH KK-T2
123-EF28 WH - 18
200-EF6 BK - 18
1
2
123-EP1
200-EP2
WH - 18
BK - 18
A
B
FUEL SHUTOFF SOL TURBO
176-6219
(ATCH) NOTE H NOTE H
1S7251
NOTE H

8X-9618 7Y-3883
WC-C1
3E3364
TO ENGINE HARNESS 123-WC1 WH - 18 FUEL SHUTOFF SOL NA
E E
1
FRAME CONN EF-C17 2 208-5029
CAB ENGINE (SH 2 LOC E-3)

FUEL SHUTOFF SOL-NA ENG

NOTE H
PE-C3
1552269 200-PE5 BK - 18 PE-C9
SIDE SHIFT LEFT SOL BK-18 1 M719-PE17 GN - 18 200-PE6 BK - 18 1552269
238-4626 BK-18 2 200-PE10 BK - 18 200-PE8 BK - 18 M720-PE12 BU - 18 1
200-PE15 BK - 18 143-PE1 BR - 18 2 NOT CONNECTED NOTE Z
614-TA2 PU - 18 F444-TA7 PU - 18 123-EF23 WH - 18 COLD START ADV SOL
200-PE7 BK - 18 STABILITY PRESS SW T (EMISSIONS ENGINE)
PE-C6 200-PE10 BK - 18 8 1 3 4 6 10 STABILITY WARNING SW TA-C3 TE-C1 TE-C2 TC-C1 TC-C2 TF-C1 TF-C2 SEE TABLE
1552269 200-PE23 BK - 18 350-1078 2304013 2304014 2304013 2304014 2304013 2304014 1552272 COLD START TEMP SW
SIDE SHIFT LEFT SUPPR 1 M719-PE18 GN - 18 TA-C2 F444-TA7 PU - 18 1 F444-TE1 PU - 18 1 F444-TC1 PU - 18 1 F444-TF1 PU - 18 1 +12V 173-7527
106-8704 2 200-PE6 BK - 18 M719-PE17 GN - 18 PE-C1 2305009 143-TA1 BR - 18 143-TA1 BR - 18 200-TA6 BK - 18 2 200-TE2 BK - 18 2 200-TC2 BK - 18 2 200-TF2 BK - 18 2 GND
M719-PE18 GN - 18 M719-PE16 GN - 18 3E3376
CONN 3 CONN 6 1 143-TA1 BR - 18 TA-C1 F443-TA3 GN - 18 3 F443-TE3 GN - 18 3 F443-TC3 GN - 18 3 F443-TF3 GN - 18 3 OUT (SWB)
EF-C7
M719-PE27 GN - 18 143-PE1 BR - 18 1
TO SIDE CONSOLE HARN 2 614-TA2 PU - 18 200-TA5 BK - 18 7 2 5 9 2285856 4
200-PE5 BK - 18 2 TO PLATFORM HARN F443-TA3 GN - 18 200-TA4 BK - 18 200-TA6 BK - 18 1552269
PE-C5 M720-PE13 BU - 18 M719-PE16 GN - 18 3 CONN PM-C38
CONN RH-C18
(VOL 1 LOC C-11)
3
4 200-TA4 BK - 18 200-TA5 BK - 18 CONN 35 CONN 36 CONN 37 X977-EF8 YL - 18 1 FUEL LIFT PUMP
1552269 MOTOR
M720-PE14 BU - 18 M720-PE12 BU - 18 M721-PE20 WH - 18 4 (VOL 1 LOC H-12) 614-TA2 PU - 18 614-TA2 PU - 18 143-TA1 BR - 18 200-EF30 BK - 18 2 228-9129
SIDE SHIFT RIGHT SOL BK-18 1 M721-PE22 WH - 18 M720-PE24 BU - 18 F443-TA3 GN - 18 F443-TA3 GN - 18 STABILITY PRESS SW
238-4626 BK-18 2 200-PE7 BK - 18 M720-PE26 BU - 18 PART COLOUR PRESS.
350-9453 BU 127 BAR
M721-PE21 WH - 18
M721-PE22 WH - 18 M721-PE20 WH - 18 200-TA6 BK - 18 200-TA6 BK - 18 350-9454 GR 145 BAR EF-C9
PE-C4 M721-PE25 WH - 18 F443-TA3 GN - 18 F443-TA3 GN - 18 350-9455 YL 162 BAR 1552269
1552269 350-9456 RD 179 BAR BK-18 123-EF53 WH - 18 123-EF53 WH - 18 1 NOT CONNECTED
SIDE SHIFT RIGHT SUPPR 1 M721-PE21 WH - 18 BK-18 309-EF49 GY - 18 2
350-9457 BR 212 BAR
106-8704 2 200-PE8 BK - 18
ENGINE BLOCK HEATER
STABILITY WARNING - ATCH 120 VAC
240 VAC
248-2214
248-2215
PE-C10
1552269 ALTERNATOR 120A
LOCKOUT SOL BK-18 1 M720-PE13 BU - 18 309-EF21 GY - 18 309-EF51 GY - 18 D+ 225-3145
238-4628 BK-18 2 200-PE23 BK - 18
450-EF38 YL - 18 450-EF38 YL - 18 W
B+

PE-C7
D LOCKOUT SUPPR 1
1552269
M720-PE14 BU - 18 EF-C8
CBL-CC1 RD - 2 D
106-8704 2 200-PE15 BK - 18 9X1054
30
106-EF11 RD - 12 106-EF11 RD - 12 1 START AID RELAY
86
123-EF10 WH - 18 123-EF10 WH - 18 5 115-1615
310-EF15 PU - 18 310-EF15 PU - 18 2
85
PE-C8 384-EF50 BU - 12 4
1552269 87
3
SIDE SHIFT SUPPR 87a
1 M720-PE24 BU - 18 ANTENNA AS.
106-8704 2 M721-PE25 WH - 18 263-7802 EF-C11
WR-C2 2219804
ANTENNA 3E5179 384-EF50 BU - 12 384-EF24 BU - 10 1 GLOW PLUGS
125-WR1 OR - 18 1
PE-C11 WR-C1 200-WR2 BK - 18 2
1552269 1552252 308-WR3 YL - 18 3
SIDE SHIFT SUPPR2 1 M720-PE26 BU - 18 BAT + 1 125-WR1 OR - 18 403-WR4 GN - 18 4 TO PROD LINK JUMPER HARN
106-8704 2 M719-PE27 GN - 18 BAT - 2 200-WR2 BK - 18 5 CONN WT-C2
614-AC15 PU - 18 KEY SW RUN 3 308-WR3 YL - 18 6 (VOL 2 LOC C-5) PRM MODULE ENG
HEATER / AC SW
E528-AC13 PU - 14 R TERM 4 403-WR4 GN - 18 7 322-6827
FUNCTION CONNECTIONS E528-AC12 PU - 14 RS-232-TXD 5 N957-WR7 PK - 18 8
HEATER ON 2&3 5&6 522-AC20 WH - 18 6 9 101-EF9 RD - 8 +BAT

AC ON 2&1 5&4 614-AC23 PU - 18 RS-232-RXD 7 N960-WR6 OR - 18 N979-WR5 GN - 18 10

POWER SIDESHIFT - ATCH 8 1 3 4 6 10
RS-232-GND
RS-232-DTR
8
9
N979-WR5
N970-WR8
GN - 18
YL - 18
N960-WR6 OR - 18
N957-WR7 PK - 18
11
12 106-EF11 RD - 12
40A

NOTE S VENT SW RS-232-DSR 10 N973-WR9 BR - 18 218-EF63 BK - 18 PRM FUSES

HEATER AC SW 214-4703 11 306-EF12 GN - 18 30A 274-9872
214-4718 NOTE M 12 WR-C3 30A
40A 278-6377
NOTE M AC-C3 3E3364
60A 267-2701
7 2 5 9 2285856 N970-WR8 YL - 18 1 CONNECTOR NOT USED
PROD LINK RADIO EF-C1
N973-WR9 BR - 18 2
263-9088 2304011
200-AC22 BK - 14 85 30
124-AC5 GN - 18 306-EF12 GN - 18 1 1
122-AC1 BU - 12 218-EF63 BK - 18 2 2

AWS SW CRAB / CIRCLE SW

200-AC8 BK - 14 122-AC1 BU - 12 122-AC24 BU - 12 PRODUCT LINK 121SR - ATCH 86
122-AC26 BU - 12 AC-C10
1552269
CONN 34 87 87A
FUNCTION CONNECTIONS FUNCTION CONNECTIONS TO AC SHUTOFF HARN
G795-WP31 OR - 18 614-AC14 PU - 18 124-AC5 GN - 18 C511-AC7 WH - 18 1 RELAY
2WS 2&1 5&4 CIRCLE 2&1 5&4 CONN AR-C2
A884-WP32 WH - 18 WA-C2 517-AC19 BU - 14 521-AC29 YL - 18 2
4WS 2&3 5&6 CRAB 2&3 5&6 (VOL 2 LOC E-6)
H768-WP36 BR - 18 1552269 A 516-AC18 GN - 14 200-AC2 BK - 18
G795-WA3 OR - 18 1 RD-18 2 WHEEL 515-AC4 GY - 18 200-AC27 BK - 12

C C
8 1 3 4 6 10 AWS SW 200-WA4 BK - 18 2 BR-18 STEER E529-AC21 YL - 14 E528-AC28 PU - 14 200-AC10 BK - 12 STARTER USB SB
343-6503 200-AC22 BK - 14 143-0539
8 1 3 4 6 10 200-AC25 BK - 14 AC-C7 304-EF64 WH - 12
G S
WA-C3
1552269 BLOWER SPEED SW
200-AC8 BK - 14 3E3370 CONN 11 106-EF11 RD - 12
WP-C3 B 200-AC9 BK - 18 124-AC5 GN - 18 A
7 2 5 9 2285856 CONN 29 A884-WA5 WH - 18 1 RD-18 4 WHEEL 214-4695 614-AC6 PU - 18 B
TO PLATFORM HARN MTR BAT 101-EF9 RD - 8 304-EF64 WH - 12
CONN PM-C35
WP-C1 WA-C1 H768-WA6 BR - 18 2 BR-18 STEER AC-C2 515-AC4 GY - 18 521-AC29 YL - 18 C
(VOL 1 LOC D-11)
200-WP38 BK - 18 143-WP20 BR - 18 143-WP20 BR - 18 143-WP20 BR - 18 3E5179 1552252 7 2 5 9 2285856 516-AC18 GN - 14 MOTOR
143-WP37 BR - 18 143-WP37 BR - 18 143-WP37 BR - 18 143-WP37 BR - 18 1 CBL-CC1 RD - 2
200-WP23 BK - 18 200-WP23 BK - 18 143-WP13 BR - 18 2 WA-C5 E529-AC21 YL - 14 200-AC25 BK - 14 517-AC19 BU - 14 CBL-AA1 RD - 00
U763-WP7 BU - 18 200-WP38 BK - 18 200-WP38 BK - 18 G795-WP3 OR - 18 3 G795-WA3 OR - 18 1552269 C E528-AC11 PU - 14 WT-C1 WT-C2
985-WP9 GY - 18 614-WP15 PU - 18 614-WP15 PU - 18 200-WP16 BK - 18 200-WP4 BK - 18 4 200-WA4 BK - 18 985-WA9 GY - 18 1 RD-18 CRAB 200-AC9 BK - 18 521-AC29 YL - 18 3E3376 1552252
H769-WP8 BR - 18 985-WP9 GY - 18 985-WP9 GY - 18 200-WP23 BK - 18 200-WP4 BK - 18 A884-WP5 WH - 18 5 A884-WA5 WH - 18 H770-WA10 BR - 18 2 BR-18 STEER AC-C1 CONN 26 1 105-WT1 RD - 18 1 NOTE A
H770-WP10 BR - 18 A884-WP32 WH - 18 A884-WP32 WH - 18 200-WP38 BK - 18 200-WP12 BK - 18 H768-WP6 BR - 18 6 H768-WA6 BR - 18 522-AC20 WH - 18 9X1054 TO PLATFORM HARN 2 202-WT2 BK - 18 2 (TO BAT POS TERM)
AC-C6 30 308-WT3 YL - 18
A884-WP33 WH - 18 A884-WP33 WH - 18 U763-WP7 BU - 18 7 U763-WA7 BU - 18 122-AC24 BU - 12 1 HI SPD RL CONN PM-C32 3 3 TO PRODUCT LINK HARN
8 1 3 4 6 10 CRAB CIRCLE SW WA-C4 1779646 86 450-WT4 YL - 18
G795-WP31 OR - 18 G795-WP31 OR - 18 614-WP15 PU - 18 H769-WP8 BR - 18 8 H769-WA8 BR - 18 515-AC4 GY - 18 5 115-1615 (VOL 1 LOC I-3) 4 4 CONN WR-C2
343-6504 H764-WP11 GY - 18 H764-WP11 GY - 18 985-WP9 GY - 18 9 985-WA9 GY - 18 1552269 D 1 C568-AC16 WH - 12 614-AC14 PU - 18 200-AC2 BK - 18 2 5 (VOL 2 LOC D-5)
BLOWER MOTOR 85
H768-WP34 BR - 18 H768-WP34 BR - 18 985-WP9 GY - 18 985-WP9 GY - 18 H770-WP10 BR - 18 10 H770-WA10 BR - 18 U763-WA7 BU - 18 1 RD-18 CIRCLE MOTOR 2 200-AC10 BK - 12 614-AC15 PU - 18 614-AC6 PU - 18 C568-AC3 WH - 12 4 6
304-8965 87
H764-WP11 GY - 18 11 H764-WA11 GY - 18 H769-WA8 BR - 18 2 BR-18 STEER 614-AC23 PU - 18 3 7
87a
WP-C4 H768-WP36 BR - 18 H768-WP36 BR - 18 A884-WP32 WH - 18 A884-WP5 WH - 18 200-WP12 BK - 18 12 200-WA12 BK - 18 8
7 2 5 9 2285856 H769-WP8 BR - 18 H769-WP8 BR - 18 A884-WP33 WH - 18 C511-AC7 WH - 18 9
H770-WP10 BR - 18 H770-WP10 BR - 18 AWS VALVE AC-C4 N979-WT5 GN - 16 10
H768-WP34 BR - 18 U763-WP7 BU - 18 U763-WP7 BU - 18 G795-WP14 OR - 18 G795-WP3 OR - 18 340-7208 3E3364 C568-AC16 WH - 12 C568-AC3 WH - 12 N960-WT6 OR - 16 11
A884-WP33 WH - 18 G795-WP31 OR - 18 THERMOSTAT WIRE AS 1 522-AC20 WH - 18 C568-AC17 WH - 12 N957-WT7 PK - 16 12
220-3762 2 C511-AC7 WH - 18 122-AC26 BU - 12 TO PRM MODULE - HVAC
143-WE1 BR- 18 H764-WP11 GY - 18 H764-WP11 GY - 18
WA-C6 AWS POSITION SNSR
NOTE B
THERMOSTAT SW
E528-AC11
E528-AC12
PU - 14
PU - 14
NOTE T
WT-C3 ENGINE
AWS POSITION GAUGE WE-C1 WP-C5 WP-C2 H768-WP34 BR - 18 H768-WP6 BR - 18 1552269 107-9677 NOTE N 119-9631 E528-AC13 PU - 14 9X4813
170-6307 3E3376 1552272 3E3376
T
N979-WT5 GN - 16 SERVICE PORT CONNECTIONS
H768-WP36 BR - 18 H764-WA11 GY - 18 1 PK-18 E528-AC28 PU - 14 A
A = GND
1 143-WP20 BR - 18 143-WP20 BR - 18 CONN 15 1 143-WP13 BR - 18 200-WA12 BK - 18 2 BK-18
AC-C9
N960-WT6 OR - 16 B
B = RXD
614-WE3 PU- 18 2 614-WP15 PU - 18 614-WP15 PU - 18 2 G795-WP14 OR - 18 H769-WP8 BR - 18 H769-WP8 BR - 18 N957-WT7 PK - 16 C
TO PLATFORM HARN MOTOR SPD RES 1779654 C = TXD
3 H764-WP11 GY - 18 H764-WP11 GY - 18 CONN PM-C54
3 614-WP15 PU - 18 H770-WP10 BR - 18 H770-WP10 BR - 18
4 200-WP23 BK - 18 200-WP23 BK - 18 (VOL 1 LOC E-8)
4 200-WP16 BK - 18 U763-WP7 BU - 18 U763-WP7 BU - 18 204-9921 1 C568-AC17 WH - 12 200-AC27 BK - 12 TO LOWER CAB GROUND STUD
2 516-AC18 GN - 14
200-WE2 BK- 18 CONN 27 3 517-AC19 BU - 14

H764-WE4 GY- 18
4 PRODUCT LINK JUMPER - ATCH
AWS GAUGE - ATCH AWS PLATFORM - ATCH AWS AXLE - ATCH AIR CONDITION - ATCH
NOTE Y NOTE Y NOTE Y

B B

WIRE GROUP COLOR DESCRIPTIONS

GROUND CIRCUIT
WIRES THAT HAVE SYSTEM VOLTAGE WHEN THE KEY SWITCH IS OFF
COLOR ABBREVIATIONS WIRES THAT HAVE SYSTEM VOLTAGE WHEN THE KEY SWITCH IS ON
SYMBOL DESCRIPTION STARTING CIRCUIT
ABBREV COLOR START AID CIRCUIT
CIRCUIT CONNECTED RD RED TRANSMISSION CONTROL CIRCUIT
MONITOR CIRCUIT
CIRCUIT NOT CONNECTED WH WHITE
CHASSIS / AWD CIRCUIT
ELECTRICAL CONNECTION TO OR ORANGE MACHINE SECURITY CONTROL CIRCUIT
MACHINE STRUCTURE
INTERNAL ELECTRICAL CONNECTION YL YELLOW HEATER AND AIR CONDITIONER CIRCUIT
TO SURFACE OF COMPONENT TURN SIGNAL / WIPER WASHER CIRCUIT
PK PINK
CONNECTOR CAT DATA LINK
BK BLACK CAN DATA LINK (J1939)
H# CIRCUIT GROUPING DESIGNATION GY GRAY RS-232 DATA LINK
PU PURPLE SIDE SHIFT CONTROL CIRCUIT
ATCH WIRE, CABLE, COMPONENT
MACHINE CONTROL CIRCUIT
BR BROWN
SPLICE
OTHER COLOR DESCRIPTIONS
A
GN GREEN
BLADE, SPADE, RING OR SCREW
TERMINAL BU BLUE HIGHWAYS
A

THIS SCHEMATIC IS FOR THE 422E, 428E, and 434E

BACKHOE LOADER - E SERIES MECHANICAL (EAME)
VOLUME 2 of 2: ENGINE, DRIVETRAIN AND ATTACHMENTS
PART NUMBER: 329-0282, CHANGE: 00, VERSION: S
Components are shown installed on a fully operable machine with the key and engine off, transmission shifter
in neutral and with parking brake set.
Refer to the appropriate Service Manual for Troubleshooting, Specifications and Systems Operations.

14 13 12 11 10 9 8 7 6 5 4 3 2 1