AvK Industrial Ratings Book 2

Alternator
Ratings Book
Industrial
Edition 2
AvK | Ratings Book Industrial
i Introduction
Rating Definitions
All ratings are based on Rise by Resistance measurement method. Ratings based on Embedded Temperature Device
(ETD) measurement may be provided under application to Cummins Generator Technologies.
Thermal Insulation Class
Insulation class governs the maximum permissible temperature an alternator can operate without damaging the insulation
system. Cummins Generator Technologies use Class H & Class F.
Insulation Maximum Permissible
Class Temperature
Class F 155 ºC
Class H 180 ºC
Temperature Rise
Temperature rise is the increase in temperature above ambient temperature 40 ºC.
Temperature Rise Temperature ºC
Class B 80 ºC
Class F 105 ºC
Class H 125 ºC
Standby application allows windings to run hotter than the Class H temperature rise limit, therefore for an ambient of
40 ºC temperature rise 150 ºC
27 ºC temperature rise 163 ºC
Generator Set Ratings

The tables below summarises the definitions according to ISO8528-1 for the generator set and a combination of
ISO8528-3 and IEC60034-1 for the alternator.
Emergency Standby Continuous

Genset Rating Limited Time Prime Prime Rated Power
Power Operating Power
(ISO8528-1) (LTP) (PRP)
(ESP) (COP)
Load type Variable Constant Variable Constant
Annual operating
200 500 Unlimited Unlimited
hours
Average load 70% 100% 70% 100%
10%
Overload No No No
(1 hour in every 12 Hrs)
Alternator Rating
Standby Standby Continuous Continuous
(NEMA MG1-32)
Duty Cycle
S10 S10 S1 S1
(IEC 60034-1)
Class H 125/40 Class H 125/40

Standby 150/40 Standby 150/40
Alternator Ratings Class F 105/40 Class F 105/40
Standby 163/27 Standby 163/27
Class B 80/40 Class B 80/40
Page 2
i
Derates
Introduction
Ambient Temperature
If the ambient (alternator air inlet temperature) exceeds 40 ºC then the alternator output rating must be reduced using the
following tables.
DSG or DIG
Utilisation Class H Class F Class B
Temperature ºC Multiplying Factor Multiplying Factor Multiplying Factor

45 0.968 0.963 0.955
50 0.935 0.925 0.910
55 0.903 0.888 0.865
60 0.870 0.850 0.820
For ambient temperatures above 60 ºC please consult applications engineering.
Altitude (Low Voltage ≤ 690V)

All ratings are based on altitude up to 1000 metres above sea level. If the altitude exceeds 1000m then the alternator
output ratings must be derated using the following table.
Altitude above sea
Multiplying Factor
level in metres
1500 0.95
2000 0.9
2500 0.85
3000 0.8
Please consult applications engineering department for

1. High Voltages (>690V)
2. Altitudes above 3000m
Page 3
i
Useful Formulas
Introduction
Useful Formulas
Useful Formulas
TO OBTAIN
kilowatts electrical
Single Phase AC power Three Phase AC power
𝑉𝑉𝑉𝑉𝑉𝑉𝑉𝑉𝑉𝑉 ×𝐴𝐴𝐴𝐴𝐴𝐴𝐴𝐴 ×𝑃𝑃𝑃𝑃 𝑉𝑉𝑉𝑉𝑉𝑉𝑉𝑉𝑉𝑉 ×𝐴𝐴𝐴𝐴𝐴𝐴𝐴𝐴 ×𝑃𝑃𝑃𝑃 × 3
(kW)
TO OBTAIN
TO OBTAIN Single Phase 1000AC power
Single Phase AC power Three Phase
1000AC power
Three Phase AC power
kilowatts
(kW)electrical 𝑉𝑉𝑉𝑉𝑉𝑉𝑉𝑉𝑉𝑉 ×𝐴𝐴𝐴𝐴𝐴𝐴𝐴𝐴 ×𝑃𝑃𝑃𝑃
𝑘𝑘𝑘𝑘𝑘𝑘 ×𝑃𝑃𝑃𝑃 𝑉𝑉𝑉𝑉𝑉𝑉𝑉𝑉𝑉𝑉 ×𝐴𝐴𝐴𝐴𝐴𝐴𝐴𝐴 ×𝑃𝑃𝑃𝑃 ×
𝑘𝑘𝑘𝑘𝑘𝑘 ×𝑃𝑃𝑃𝑃 3
(kW)
(kW) 1000 1000
kilowatts mechanical 𝑘𝑘𝑘𝑘𝑘𝑘 ×𝑃𝑃𝑃𝑃 𝑘𝑘𝑘𝑘𝑘𝑘 ×𝑃𝑃𝑃𝑃
(kWm)
(kW)
(kW) 𝑘𝑘𝑘𝑘𝑘𝑘 ×𝑃𝑃𝑃𝑃
𝐴𝐴𝐴𝐴𝐴𝐴𝐴𝐴𝐴𝐴𝐴𝐴𝐴𝐴𝐴𝐴𝐴𝐴𝐴𝐴 𝐸𝐸𝐸𝐸𝐸𝐸𝐸𝐸𝐸𝐸𝐸𝐸𝐸𝐸𝐸𝐸𝐸𝐸𝐸𝐸 𝑘𝑘𝑘𝑘𝑘𝑘 ×𝑃𝑃𝑃𝑃
𝐴𝐴𝐴𝐴𝐴𝐴𝐴𝐴𝐴𝐴𝐴𝐴𝐴𝐴𝐴𝐴𝐴𝐴𝐴𝐴 𝐸𝐸𝐸𝐸𝐸𝐸𝐸𝐸𝐸𝐸𝐸𝐸𝐸𝐸𝐸𝐸𝐸𝐸𝐸𝐸
kilowatts kVA
mechanical 𝑉𝑉𝑉𝑉𝑉𝑉𝑉𝑉𝑉𝑉 ×𝐴𝐴𝐴𝐴𝐴𝐴𝐴𝐴
kilowatts mechanical 𝑘𝑘𝑘𝑘𝑘𝑘 ×𝑃𝑃𝑃𝑃 𝑉𝑉𝑉𝑉𝑉𝑉𝑉𝑉𝑉𝑉 ×𝐴𝐴𝐴𝐴𝐴𝐴𝐴𝐴 ×
𝑘𝑘𝑘𝑘𝑘𝑘 ×𝑃𝑃𝑃𝑃 3
(kWm)
(kWm)
1000
𝐴𝐴𝐴𝐴𝐴𝐴𝐴𝐴𝐴𝐴𝐴𝐴𝐴𝐴𝐴𝐴𝐴𝐴𝐴𝐴 𝐸𝐸𝐸𝐸𝐸𝐸𝐸𝐸𝐸𝐸𝐸𝐸𝐸𝐸𝐸𝐸𝐸𝐸𝐸𝐸 1000
𝐴𝐴𝐴𝐴𝐴𝐴𝐴𝐴𝐴𝐴𝐴𝐴𝐴𝐴𝐴𝐴𝐴𝐴𝐴𝐴 𝐸𝐸𝐸𝐸𝐸𝐸𝐸𝐸𝐸𝐸𝐸𝐸𝐸𝐸𝐸𝐸𝐸𝐸𝐸𝐸
kVA
Amps 𝑘𝑘𝑘𝑘𝑘𝑘×1000
𝑉𝑉𝑉𝑉𝑉𝑉𝑉𝑉𝑉𝑉 ×𝐴𝐴𝐴𝐴𝐴𝐴𝐴𝐴
𝑘𝑘𝑘𝑘𝑘𝑘×1000
𝑉𝑉𝑉𝑉𝑉𝑉𝑉𝑉𝑉𝑉 ×𝐴𝐴𝐴𝐴𝐴𝐴𝐴𝐴 × 3
kVA 𝑉𝑉𝑉𝑉𝑉𝑉𝑉𝑉𝑉𝑉 𝑉𝑉𝑉𝑉𝑉𝑉𝑡𝑡𝑡𝑡 × 3
Speed (rpm)
1000 1000
Amps 120×𝐹𝐹𝐹𝐹𝐹𝐹𝐹𝐹𝐹𝐹𝐹𝐹𝐹𝐹𝐹𝐹𝐹𝐹
𝑘𝑘𝑘𝑘𝑘𝑘×1000 120×𝐹𝐹𝐹𝐹𝐹𝐹𝐹𝐹𝐹𝐹𝐹𝐹𝐹𝐹𝐹𝐹𝐹𝐹
𝑘𝑘𝑘𝑘𝑘𝑘×1000
Amps # 𝑃𝑃𝑃𝑃𝑃𝑃𝑃𝑃𝑃𝑃
𝑉𝑉𝑉𝑉𝑉𝑉𝑉𝑉𝑉𝑉
# 𝑃𝑃𝑃𝑃𝑃𝑃𝑃𝑃𝑃𝑃 3
𝑉𝑉𝑉𝑉𝑉𝑉𝑡𝑡𝑡𝑡 ×
Reactive
SpeedPower (kVAr)
(rpm) 𝑉𝑉𝑉𝑉𝑉𝑉𝑉𝑉𝑉𝑉 ×𝐴𝐴𝐴𝐴𝐴𝐴𝐴𝐴 ×𝑠𝑠𝑠𝑠𝑠𝑠∅
120×𝐹𝐹𝐹𝐹𝐹𝐹𝐹𝐹𝐹𝐹𝐹𝐹𝐹𝐹𝐹𝐹𝐹𝐹 𝑉𝑉𝑉𝑉𝑉𝑉𝑉𝑉𝑉𝑉 ×𝐴𝐴𝐴𝐴𝐴𝐴𝐴𝐴×
120×𝐹𝐹𝐹𝐹𝐹𝐹𝐹𝐹𝐹𝐹𝐹𝐹𝐹𝐹𝐹𝐹𝐹𝐹 3 × 𝑠𝑠𝑠𝑠𝑠𝑠∅
Speed (rpm)
1000
# 𝑃𝑃𝑃𝑃𝑃𝑃𝑃𝑃𝑃𝑃 1000
# 𝑃𝑃𝑃𝑃𝑃𝑃𝑃𝑃𝑃𝑃
% Voltage
Reactiveregulation (for steady
Power (kVAr) 𝑉𝑉!" − 𝑉𝑉!" 𝑉𝑉!" − 𝑉𝑉!"
loads, Reactive
from No–Load to Full– 𝑉𝑉𝑉𝑉𝑉𝑉𝑉𝑉𝑉𝑉 ×𝐴𝐴𝐴𝐴𝐴𝐴𝐴𝐴 ×𝑠𝑠𝑠𝑠𝑠𝑠∅
×100 𝑉𝑉𝑉𝑉𝑉𝑉𝑉𝑉𝑉𝑉 ×𝐴𝐴𝐴𝐴𝐴𝐴𝐴𝐴× 3 × 𝑠𝑠𝑠𝑠𝑠𝑠∅
×100
Power (kVAr)
Load) 𝑉𝑉!"1000 𝑉𝑉!"
1000
%% Frequency
Voltage Regulation
% regulation
Voltage regulation
(for
(for steady 𝐹𝐹!"
𝑉𝑉!" − − 𝑉𝑉
𝐹𝐹!"
!" 𝐹𝐹!"
𝑉𝑉 − 𝑉𝑉
!" − 𝐹𝐹!"
!"
steady
loads, loads from No–Load to ×100
×100 ×100
×100
(forfrom No–Load
Steady- to Full–
Loads, from No–
Full–Load) 𝐹𝐹!"
𝑉𝑉!" 𝐹𝐹!"
𝑉𝑉!"
Load)
Load
to Full–Load)
Horsepower
% Frequencyrequired to drive
Regulation (for 𝐹𝐹!" − 𝑘𝑘𝑘𝑘
𝐹𝐹!" 𝐹𝐹!" − 𝐹𝐹𝑘𝑘𝑘𝑘
!"
steadyHorsepower
loads fromrequired
alternatorNo–Load to to
×100 ×100
drive alternator
Full–Load) 0.746 ×𝐴𝐴𝐴𝐴𝐴𝐴𝐴𝐴𝐴𝐴𝐴𝐴𝐴𝐴𝐴𝐴𝐴𝐴𝐴𝐴 𝐸𝐸𝐸𝐸𝐸𝐸𝐸𝐸𝐸𝐸𝐸𝐸𝐸𝐸𝐸𝐸𝐸𝐸𝐸𝐸
𝐹𝐹!" 0.746 ×𝐴𝐴𝐴𝐴𝐴𝐴𝐴𝐴𝐴𝐴𝐴𝐴𝐴𝐴𝐴𝐴𝐴𝐴𝐴𝐴 𝐸𝐸𝐸𝐸𝐸𝐸𝐸𝐸𝐸𝐸𝐸𝐸𝐸𝐸𝐸𝐸𝐸𝐸𝐸𝐸
𝐹𝐹!"
First cycle
Horsepower RMS shorttocircuit
required drive 𝑅𝑅𝑅𝑅𝑅𝑅𝑅𝑅𝑅𝑅 𝐴𝐴𝐴𝐴𝐴𝐴𝐴𝐴𝐴𝐴𝐴𝐴𝐴𝐴 𝑅𝑅𝑅𝑅𝑅𝑅𝑅𝑅𝑅𝑅 𝐴𝐴𝐴𝐴𝐴𝐴𝐴𝐴𝐴𝐴𝐴𝐴𝐴𝐴
First cycle
current RMS short
(±10%) 𝑘𝑘𝑘𝑘 𝑘𝑘𝑘𝑘
alternator
circuit current (±10%) 𝑝𝑝𝑝𝑝𝑝𝑝′′𝑑𝑑 𝑝𝑝𝑝𝑝𝑝𝑝′′𝑑𝑑
0.746 ×𝐴𝐴𝐴𝐴𝐴𝐴𝐴𝐴𝐴𝐴𝐴𝐴𝐴𝐴𝐴𝐴𝐴𝐴𝐴𝐴 𝐸𝐸𝐸𝐸𝐸𝐸𝐸𝐸𝐸𝐸𝐸𝐸𝐸𝐸𝐸𝐸𝐸𝐸𝐸𝐸 0.746 ×𝐴𝐴𝐴𝐴𝐴𝐴𝐴𝐴𝐴𝐴𝐴𝐴𝐴𝐴𝐴𝐴𝐴𝐴𝐴𝐴 𝐸𝐸𝐸𝐸𝐸𝐸𝐸𝐸𝐸𝐸𝐸𝐸𝐸𝐸𝐸𝐸𝐸𝐸𝐸𝐸
First cycle RMS short circuit 𝑅𝑅𝑅𝑅𝑅𝑅𝑅𝑅𝑅𝑅 𝐴𝐴𝐴𝐴𝐴𝐴𝐴𝐴𝐴𝐴𝐴𝐴𝐴𝐴 𝑅𝑅𝑅𝑅𝑅𝑅𝑅𝑅𝑅𝑅 𝐴𝐴𝐴𝐴𝐴𝐴𝐴𝐴𝐴𝐴𝐴𝐴𝐴𝐴
“PF” refers
• current to power factor, which is
(±10%) expressed as a decimal fraction. For example, 80% power

factor = 0.8 for the purposes of calculations.𝑝𝑝𝑝𝑝𝑝𝑝′′𝑑𝑑 𝑝𝑝𝑝𝑝𝑝𝑝′′𝑑𝑑
• “Sin∅” refers to power factor, where “∅” = PF. For example, 80% power factor = 0.8, therefore “Sin∅”
=“Sin(0.8)”
• # Poles refers to number of Poles
• “Volts” refers to line–to–line voltage.
• “Amps” refers to line current in amperes.
• “pu” refers to per unit
Page 4
Table of Contents
4 POLE low Voltage Page

50Hz 1500rpm
400V Page 8
690V Page 9
60Hz 1800rpm
480V Page 10
600V Page 10
690V Page 11
4 POLE High Voltage Page

50Hz 1500rpm
3300V Page 12
6300V Page 13
6600V Page 14
10500V Page 15
11000V Page 16
60Hz 1800rpm
4160V Page 17
6600V Page 18
13800V Page 19

50Hz 1000rpm
400V Page 20
690V Page 21
60Hz 1200rpm
480V Page 22
600V Page 23
690V Page 24
Page 5
Table of Contents

50Hz 1000rpm
3300V Page 25
6300V Page 26
6600V Page 27
10500V Page 28
11000V Page 29
60Hz 1200rpm
4160V Page 30
6600V Page 30
13800V Page 31

50Hz 750rpm
400V Page 32
690V Page 33
60Hz 900rpm
480V Page 34
600V Page 35
690V Page 36

50Hz 750rpm
3300V Page 37
6300V Page 38
6600V Page 39
10500V Page 40
11000V Page 40
60Hz 900rpm
4160V Page 41
6600V Page 41
13800V Page 42
Page 6
Table of Contents

50Hz 600rpm
400V Page 43
690V Page 44
60Hz 720rpm
480V Page 45
690V Page 46

50Hz 600rpm
3300V Page 47
6300V Page 47
6600V Page 48
10500V Page 48
11000V Page 49
60Hz 720rpm
4160V Page 49
6600V Page 50
13800V Page 50
Page 7
4 POLE Low Voltage

50Hz/1500rpm
Star 400V
0.8 Power Factor
TEMPERATURE RISE
Standby Standby Continuous Continuous Continuous

163/27 150/40 125/40 (H) 105/40 (F) 80/40 (B)
Model kVA kW kVA kW kVA kW kVA kW kVA kW
DSG 62 M1/4 726 581 680 544 660 528 568 454 462 370
DSG 62 M2/4 825 660 773 618 750 600 645 516 525 420
DSG 62 L1/4 990 792 927 742 900 720 774 619 630 504
DSG 62 L2/4 1210 968 1133 906 1100 880 946 757 770 616
DSG 74 M1/4 1540 1232 1442 1154 1400 1120 1204 963 980 784
DSG 74 M2/4 1716 1373 1607 1285 1560 1248 1342 1073 1092 874
DSG 74 L1/4 1925 1540 1803 1442 1750 1400 1505 1204 1225 980
DSG 74 L2/4 2200 1760 2060 1648 2000 1600 1720 1376 1400 1120
DSG 86 K1/4 2266 1813 2122 1697 2060 1648 1875 1500 1648 1318
DSG 86 M1/4 2640 2112 2472 1978 2400 1920 2184 1747 1920 1536
DSG 86 L1/4 3124 2499 2925 2340 2840 2272 2584 2068 2272 1818
DSG 99 K1/4 3795 3036 3554 2843 3450 2760 3140 2512 2760 2208
DSG 114 K1/4 4361 3489 4120 3296 4000 3200 3720 2976 3280 2624
Page 8
4 POLE Low Voltage
50Hz/1500rpm
Star 690V
0.8 Power Factor
TEMPERATURE RISE

163/27 150/40 125/40 (H) 105/40 (F) 80/40 (B)
DSG 62 M1/4 715 572 670 536 650 520 559 447 455 364
DSG 62 M2/4 858 686 803 643 780 624 671 537 546 437
DSG 62 L1/4 946 757 886 709 860 688 740 592 602 482
DSG 62 L2/4 1210 968 1133 906 1100 880 946 757 770 616
DSG 74 M1/4 1452 1162 1360 1088 1320 1056 1135 908 924 739
DSG 74 M2/4 1650 1320 1545 1236 1500 1200 1290 1032 1050 840
DSG 74 L1/4 1914 1531 1792 1434 1740 1392 1496 1197 1218 974
DSG 74 L2/4 2090 1672 1957 1566 1900 1520 1634 1307 1330 1064
DSG 86 K1/4 2222 1778 2081 1664 2020 1616 1838 1471 1616 1293
DSG 86 M1/4 2657 2125 2487 1990 2415 1932 2198 1758 1932 1546
DSG 86 L1/4 3289 2631 3080 2464 2990 2392 2721 2177 2392 1914
DSG 99 K1/4 3861 3089 3615 2892 3510 2808 3194 2555 2808 2246
DSG 99 M1/4 4543 3634 4254 3403 4130 3304 3758 3007 3304 2643
DSG 99 L1/4 5170 4136 4841 3873 4700 3760 4277 3422 3760 3008
Page 9
4 POLE Low Voltage
60Hz/1800rpm
Star 480V
0.8 Power Factor
TEMPERATURE RISE

163/27 150/40 125/40 (H) 105/40 (F) 80/40 (B)
DSG 62 M1/4 869 695 814 651 790 632 679 544 553 442
DSG 62 M2/4 990 792 927 742 900 720 774 619 630 504
DSG 62 L1/4 1188 950 1112 890 1080 864 929 743 756 605
DSG 62 L2/4 1452 1162 1360 1088 1320 1056 1135 908 924 739
DSG 74 M1/4 1848 1478 1730 1384 1680 1344 1445 1156 1176 941
DSG 74 M2/4 2057 1646 1926 1541 1870 1496 1608 1287 1309 1047
DSG 74 L1/4 2310 1848 2163 1730 2100 1680 1806 1445 1470 1176
DSG 74 L2/4 2640 2112 2472 1978 2400 1920 2064 1651 1680 1344
DSG 86 K1/4 2719 2175 2546 2037 2472 1978 2250 1800 1978 1582
DSG 86 M1/4 3168 2534 2966 2373 2880 2304 2621 2097 2304 1843
DSG 86 L1/4 3749 2999 3510 2808 3408 2726 3101 2481 2726 2181
DSG 99 K1/4 4554 3643 4264 3411 4140 3312 3767 3014 3312 2650
DSG 114 K1/4 5233 4186 4944 3955 4800 3840 4464 3571 3936 3149
60Hz/1800rpm
Star 600V
0.8 Power Factor
TEMPERATURE RISE

163/27 150/40 125/40 (H) 105/40 (F) 80/40 (B)

DSG 86 K1/4 2219 1775 2078 1662 2017 1614 1836 1469 1614 1291
DSG 86 M1/4 2583 2066 2418 1935 2348 1878 2137 1709 1878 1503
DSG 86 L1/4 2965 2372 2777 2221 2696 2157 2453 1962 2157 1725
DSG 99 K0/4 3357 2686 3144 2515 3052 2442 2777 2222 2442 1953
DSG 99 K1/4 3950 3160 3699 2959 3591 2873 3268 2614 2873 2298
DSG 99 M1/4 4496 3597 4210 3368 4087 3270 3719 2975 3270 2616
DSG 99 L1/4 5070 4056 4747 3798 4609 3687 4194 3355 3687 2950
Page 10
4 POLE Low Voltage
60Hz/1800rpm
Star 690V
0.8 Power Factor
TEMPERATURE RISE

163/27 150/40 125/40 (H) 105/40 (F) 80/40 (B)
DSG 62 M1/4 858 686 803 643 780 624 671 537 546 437
DSG 62 M2/4 946 757 886 709 860 688 740 592 602 482
DSG 62 L1/4 1210 968 1133 906 1100 880 946 757 770 616
DSG 62 L2/4 1430 1144 1339 1071 1300 1040 1118 894 910 728
DSG 74 M1/4 1650 1320 1545 1236 1500 1200 1290 1032 1050 840
DSG 74 M2/4 1914 1531 1792 1434 1740 1392 1496 1197 1218 974
DSG 74 L1/4 2310 1848 2163 1730 2100 1680 1806 1445 1470 1176
DSG 74 L2/4 2541 2033 2379 1903 2310 1848 1987 1589 1617 1294
DSG 86 K1/4 2552 2042 2390 1912 2320 1856 2111 1689 1856 1485
DSG 86 M1/4 2970 2376 2781 2225 2700 2160 2457 1966 2160 1728
DSG 86 L1/4 3410 2728 3193 2554 3100 2480 2821 2257 2480 1984
DSG 99 K0/4 3861 3089 3615 2892 3510 2808 3194 2555 2808 2246
DSG 99 K1/4 4543 3634 4254 3403 4130 3304 3758 3007 3304 2643
DSG 99 M1/4 5170 4136 4841 3873 4700 3760 4277 3422 3760 3008
DSG 99 L1/4 5830 4664 5459 4367 5300 4240 4823 3858 4240 3392
Page 11
4 POLE High Voltage
50Hz/1500rpm
Star 3300V
0.8 Power Factor
TEMPERATURE RISE

138/27 125/40 105/40 (F) 80/40 (B)
Model kVA kW kVA kW kVA kW kVA kW
DIG 110 g/4 833 666 788 630 750 600 660 528
DIG 110 h/4 999 799 945 756 900 720 792 634
DIG 110 i/4 1199 959 1134 907 1080 864 950 760
DIG 120 g/4 1443 1154 1365 1092 1300 1040 1144 915
DIG 120 h/4 1665 1332 1575 1260 1500 1200 1320 1056
DIG 120 i/4 1943 1554 1838 1470 1750 1400 1540 1232
DIG 120 k/4 2276 1820 2153 1722 2050 1640 1804 1443
DIG 130 h/4 2498 1998 2363 1890 2250 1800 1980 1584
DIG 130 i/4 2886 2309 2730 2184 2600 2080 2288 1830
DIG 130 k/4 3330 2664 3150 2520 3000 2400 2640 2112
DIG 130 l/4 3663 2930 3465 2772 3300 2640 2904 2323
DIG 142 c/4 4174 3339 3948 3158 3760 3008 3309 2647
DIG 130 m/4 4274 3419 4043 3234 3850 3080 3388 2710
DIG 142 d/4 4496 3596 4253 3402 4050 3240 3564 2851
DIG 142 f/4 5328 4262 5040 4032 4800 3840 4224 3379
DIG 156 i/4 5384 4307 5093 4074 4850 3880 4268 3414
DIG 142 g/4 5606 4484 5303 4242 5050 4040 4444 3555
DIG 150 k/4 5661 4529 5355 4284 5100 4080 4488 3590
DIG 150 l/4 6438 5150 6090 4872 5800 4640 5104 4083
DIG 142 i/4 6438 5150 6090 4872 5800 4640 5104 4083
DIG 156 l/4 7104 5683 6720 5376 6400 5120 5632 4506
DIG 150 m/4 7215 5772 6825 5460 6500 5200 5720 4576
DIG 150 n/4 7437 5950 7035 5628 6700 5360 5896 4717
DIG 156 m/4 8103 6482 7665 6132 7300 5840 6424 5139
DIG 150 o/4 8214 6571 7770 6216 7400 5920 6512 5210
DIG 156 n/4 8769 7015 8295 6636 7900 6320 6952 5562
DIG 156 o/4 9324 7459 8820 7056 8400 6720 7392 5914
Page 12
4 POLE High Voltage
50Hz/1500rpm
Star 6300V
0.8 Power Factor
TEMPERATURE RISE

138/27 125/40 105/40 (F) 80/40 (B)
DIG 110 g/4 833 666 788 630 750 600 660 528
DIG 110 h/4 999 799 945 756 900 720 792 634
DIG 110 i/4 1199 959 1134 907 1080 864 950 760
DIG 120 g/4 1443 1154 1365 1092 1300 1040 1144 915
DIG 120 h/4 1665 1332 1575 1260 1500 1200 1320 1056
DIG 120 i/4 1943 1554 1838 1470 1750 1400 1540 1232
DIG 130 g/4 2109 1687 1995 1596 1900 1520 1672 1338
DIG 130 h/4 2387 1909 2258 1806 2150 1720 1892 1514
DIG 130 i/4 2886 2309 2730 2184 2600 2080 2288 1830
DIG 130 k/4 3330 2664 3150 2520 3000 2400 2640 2112
DIG 142 c/4 4174 3339 3948 3158 3760 3008 3309 2647
DIG 142 d/4 4496 3596 4253 3402 4050 3240 3564 2851
DIG 142 e/4 4940 3952 4673 3738 4450 3560 3916 3133
DIG 156 i/4 5273 4218 4988 3990 4750 3800 4180 3344
DIG 142 f/4 5328 4262 5040 4032 4800 3840 4224 3379
DIG 142 g/4 5606 4484 5303 4242 5050 4040 4444 3555
DIG 150 k/4 5661 4529 5355 4284 5100 4080 4488 3590
DIG 142 h/4 5883 4706 5565 4452 5300 4240 4664 3731
DIG 150 l/4 6272 5017 5933 4746 5650 4520 4972 3978
DIG 142 i/4 6438 5150 6090 4872 5800 4640 5104 4083
DIG 156 l/4 6882 5506 6510 5208 6200 4960 5456 4365
DIG 150 m/4 6993 5594 6615 5292 6300 5040 5544 4435
DIG 150 n/4 7604 6083 7193 5754 6850 5480 6028 4822
DIG 150 o/4 7770 6216 7350 5880 7000 5600 6160 4928
DIG 156 m/4 7992 6394 7560 6048 7200 5760 6336 5069
DIG 156 n/4 8658 6926 8190 6552 7800 6240 6864 5491
DIG 156 o/4 9324 7459 8820 7056 8400 6720 7392 5914
DIG 156 p/4 10101 8081 9555 7644 9100 7280 8008 6406
DIG 156 q/4 10434 8347 9870 7896 9400 7520 8272 6618
Page 13
4 POLE High Voltage
50Hz/1500rpm
Star 6600V
0.8 Power Factor
TEMPERATURE RISE

138/27 125/40 105/40 (F) 80/40 (B)
DIG 110 g/4 833 666 788 630 750 600 660 528
DIG 110 h/4 999 799 945 756 900 720 792 634
DIG 110 i/4 1199 959 1134 907 1080 864 950 760
DIG 120 g/4 1443 1154 1365 1092 1300 1040 1144 915
DIG 120 h/4 1665 1332 1575 1260 1500 1200 1320 1056
DIG 120 i/4 1943 1554 1838 1470 1750 1400 1540 1232
DIG 130 g/4 2109 1687 1995 1596 1900 1520 1672 1338
DIG 130 h/4 2387 1909 2258 1806 2150 1720 1892 1514
DIG 130 i/4 2886 2309 2730 2184 2600 2080 2288 1830
DIG 130 k/4 3330 2664 3150 2520 3000 2400 2640 2112
DIG 142 c/4 4174 3339 3948 3158 3760 3008 3309 2647
DIG 142 d/4 4496 3596 4253 3402 4050 3240 3564 2851
DIG 142 e/4 4940 3952 4673 3738 4450 3560 3916 3133
DIG 156 i/4 5273 4218 4988 3990 4750 3800 4180 3344
DIG 142 f/4 5328 4262 5040 4032 4800 3840 4224 3379
DIG 142 g/4 5606 4484 5303 4242 5050 4040 4444 3555
DIG 150 k/4 5661 4529 5355 4284 5100 4080 4488 3590
DIG 142 h/4 5883 4706 5565 4452 5300 4240 4664 3731
DIG 150 l/4 6272 5017 5933 4746 5650 4520 4972 3978
DIG 142 i/4 6438 5150 6090 4872 5800 4640 5104 4083
DIG 156 l/4 6882 5506 6510 5208 6200 4960 5456 4365
DIG 150 m/4 6993 5594 6615 5292 6300 5040 5544 4435
DIG 150 n/4 7437 5950 7035 5628 6700 5360 5896 4717
DIG 150 o/4 7770 6216 7350 5880 7000 5600 6160 4928
DIG 156 m/4 7992 6394 7560 6048 7200 5760 6336 5069
DIG 156 n/4 8658 6926 8190 6552 7800 6240 6864 5491
DIG 156 o/4 9324 7459 8820 7056 8400 6720 7392 5914
DIG 156 p/4 10101 8081 9555 7644 9100 7280 8008 6406
DIG 156 q/4 10434 8347 9870 7896 9400 7520 8272 6618
Page 14
4 POLE High Voltage
50Hz/1500rpm
Star 10500V
0.8 Power Factor
TEMPERATURE RISE

138/27 125/40 105/40 (F) 80/40 (B)
DIG 110 h/4 999 799 945 756 900 720 792 634
DIG 110 i/4 1199 959 1134 907 1080 864 950 760
DIG 120 g/4 1277 1021 1208 966 1150 920 1012 810
DIG 120 h/4 1521 1217 1439 1151 1370 1096 1206 964
DIG 120 i/4 1832 1465 1733 1386 1650 1320 1452 1162
DIG 130 g/4 1998 1598 1890 1512 1800 1440 1584 1267
DIG 130 h/4 2331 1865 2205 1764 2100 1680 1848 1478
DIG 130 i/4 2775 2220 2625 2100 2500 2000 2200 1760
DIG 130 k/4 3108 2486 2940 2352 2800 2240 2464 1971
DIG 142 c/4 4174 3339 3948 3158 3760 3008 3309 2647
DIG 142 d/4 4496 3596 4253 3402 4050 3240 3564 2851
DIG 142 e/4 4940 3952 4673 3738 4450 3560 3916 3133
DIG 156 i/4 4995 3996 4725 3780 4500 3600 3960 3168
DIG 142 f/4 5328 4262 5040 4032 4800 3840 4224 3379
DIG 150 k/4 5550 4440 5250 4200 5000 4000 4400 3520
DIG 142 g/4 5606 4484 5303 4242 5050 4040 4444 3555
DIG 142 h/4 5883 4706 5565 4452 5300 4240 4664 3731
DIG 150 l/4 5994 4795 5670 4536 5400 4320 4752 3802
DIG 142 i/4 6438 5150 6090 4872 5800 4640 5104 4083
DIG 156 l/4 6660 5328 6300 5040 6000 4800 5280 4224
DIG 150 m/4 6716 5372 6353 5082 6050 4840 5324 4259
DIG 150 n/4 7215 5772 6825 5460 6500 5200 5720 4576
DIG 156 m/4 7770 6216 7350 5880 7000 5600 6160 4928
DIG 156 n/4 8436 6749 7980 6384 7600 6080 6688 5350
DIG 156 o/4 9213 7370 8715 6972 8300 6640 7304 5843
DIG 156 p/4 9990 7992 9450 7560 9000 7200 7920 6336
DIG 156 q/4 10323 8258 9765 7812 9300 7440 8184 6547
Page 15
4 POLE High Voltage
50Hz/1500rpm
Star 11000V
0.8 Power Factor
TEMPERATURE RISE

138/27 125/40 105/40 (F) 80/40 (B)
DIG 110 h/4 999 799 945 756 900 720 792 634
DIG 110 i/4 1199 959 1134 907 1080 864 950 760
DIG 120 g/4 1277 1021 1208 966 1150 920 1012 810
DIG 120 h/4 1521 1217 1439 1151 1370 1096 1206 964
DIG 120 i/4 1832 1465 1733 1386 1650 1320 1452 1162
DIG 130 g/4 1998 1598 1890 1512 1800 1440 1584 1267
DIG 130 h/4 2331 1865 2205 1764 2100 1680 1848 1478
DIG 130 i/4 2775 2220 2625 2100 2500 2000 2200 1760
DIG 130 k/4 3108 2486 2940 2352 2800 2240 2464 1971
DIG 142 c/4 4174 3339 3948 3158 3760 3008 3309 2647
DIG 142 d/4 4496 3596 4253 3402 4050 3240 3564 2851
DIG 142 e/4 4940 3952 4673 3738 4450 3560 3916 3133
DIG 142 f/4 5328 4262 5040 4032 4800 3840 4224 3379
DIG 150 k/4 5439 4351 5145 4116 4900 3920 4312 3450
DIG 142 g/4 5606 4484 5303 4242 5050 4040 4444 3555
DIG 142 h/4 5883 4706 5565 4452 5300 4240 4664 3731
DIG 150 l/4 6105 4884 5775 4620 5500 4400 4840 3872
DIG 142 i/4 6438 5150 6090 4872 5800 4640 5104 4083
DIG 150 m/4 6605 5284 6248 4998 5950 4760 5236 4189
DIG 156 l/4 6660 5328 6300 5040 6000 4800 5280 4224
DIG 150 n/4 7215 5772 6825 5460 6500 5200 5720 4576
DIG 156 m/4 7770 6216 7350 5880 7000 5600 6160 4928
DIG 156 n/4 8436 6749 7980 6384 7600 6080 6688 5350
DIG 156 o/4 9213 7370 8715 6972 8300 6640 7304 5843
DIG 156 p/4 9990 7992 9450 7560 9000 7200 7920 6336
DIG 156 q/4 10323 8258 9765 7812 9300 7440 8184 6547
DIG 156 q/4 10323 8258 9765 7812 9300 7440 8184 6547
Page 16
4 POLE High Voltage
60Hz/1800rpm
Star 4160V
0.8 Power Factor
TEMPERATURE RISE

138/27 125/40 105/40 (F) 80/40 (B)
DIG 110 g/4 999 799 945 756 900 720 792 634
DIG 110 h/4 1199 959 1134 907 1080 864 950 760
DIG 110 i/4 1443 1154 1365 1092 1300 1040 1144 915
DIG 120 g/4 1809 1447 1712 1369 1630 1304 1434 1148
DIG 120 h/4 2109 1687 1995 1596 1900 1520 1672 1338
DIG 120 i/4 2442 1954 2310 1848 2200 1760 1936 1549
DIG 120 k/4 2886 2309 2730 2184 2600 2080 2288 1830
DIG 130 h/4 3164 2531 2993 2394 2850 2280 2508 2006
DIG 130 i/4 3497 2797 3308 2646 3150 2520 2772 2218
DIG 130 k/4 3996 3197 3780 3024 3600 2880 3168 2534
DIG 130 l/4 4440 3552 4200 3360 4000 3200 3520 2816
DIG 142 c/4 4800 3840 4540 3632 4324 3459 3805 3044
DIG 142 d/4 5170 4136 4890 3912 4658 3726 4099 3279
DIG 142 f/4 6127 4902 5796 4637 5520 4416 4858 3886
DIG 150 k/4 6327 5062 5985 4788 5700 4560 5016 4013
DIG 156 i/4 6327 5062 5985 4788 5700 4560 5016 4013
DIG 142 g/4 6494 5195 6143 4914 5850 4680 5148 4118
DIG 150 l/4 6993 5594 6615 5292 6300 5040 5544 4435
DIG 142 i/4 7437 5950 7035 5628 6700 5360 5896 4717
DIG 150 m/4 7992 6394 7560 6048 7200 5760 6336 5069
DIG 156 l/4 8547 6838 8085 6468 7700 6160 6776 5421
DIG 150 n/4 8991 7193 8505 6804 8100 6480 7128 5702
DIG 150 o/4 9435 7548 8925 7140 8500 6800 7480 5984
DIG 156 m/4 9768 7814 9240 7392 8800 7040 7744 6195
DIG 156 n/4 10434 8347 9870 7896 9400 7520 8272 6618
DIG 156 o/4 11322 9058 10710 8568 10200 8160 8976 7181
Page 17
4 POLE High Voltage
60Hz/1800rpm
Star 6600V
0.8 Power Factor
TEMPERATURE RISE

138/27 125/40 105/40 (F) 80/40 (B)
DIG 110 g/4 999 799 945 756 900 720 792 634
DIG 110 h/4 1166 932 1103 882 1050 840 924 739
DIG 110 i/4 1388 1110 1313 1050 1250 1000 1100 880
DIG 120 g/4 1665 1332 1575 1260 1500 1200 1320 1056
DIG 120 h/4 1943 1554 1838 1470 1750 1400 1540 1232
DIG 120 i/4 2442 1954 2310 1848 2200 1760 1936 1549
DIG 130 g/4 2442 1954 2310 1848 2200 1760 1936 1549
DIG 130 h/4 2664 2131 2520 2016 2400 1920 2112 1690
DIG 130 i/4 3330 2664 3150 2520 3000 2400 2640 2112
DIG 130 k/4 3830 3064 3623 2898 3450 2760 3036 2429
DIG 142 c/4 4718 3774 4463 3570 4250 3400 3740 2992
DIG 142 d/4 5106 4085 4830 3864 4600 3680 4048 3238
DIG 142 e/4 5661 4529 5355 4284 5100 4080 4488 3590
DIG 156 i/4 6105 4884 5775 4620 5500 4400 4840 3872
DIG 142 f/4 6216 4973 5880 4704 5600 4480 4928 3942
DIG 150 k/4 6327 5062 5985 4788 5700 4560 5016 4013
DIG 142 g/4 6660 5328 6300 5040 6000 4800 5280 4224
DIG 150 l/4 6993 5594 6615 5292 6300 5040 5544 4435
DIG 142 h/4 7326 5861 6930 5544 6600 5280 5808 4646
DIG 150 m/4 7992 6394 7560 6048 7200 5760 6336 5069
DIG 156 l/4 7992 6394 7560 6048 7200 5760 6336 5069
DIG 150 n/4 8603 6882 8138 6510 7750 6200 6820 5456
DIG 150 o/4 8880 7104 8400 6720 8000 6400 7040 5632
DIG 156 m/4 9435 7548 8925 7140 8500 6800 7480 5984
DIG 156 n/4 10101 8081 9555 7644 9100 7280 8008 6406
Page 18
4 POLE High Voltage
60Hz/1800rpm
Star 13800V
0.8 Power Factor
TEMPERATURE RISE

138/27 125/40 105/40 (F) 80/40 (B)
DIG 130 g/4 2276 1820 2153 1722 2050 1640 1804 1443
DIG 130 h/4 2609 2087 2468 1974 2350 1880 2068 1654
DIG 130 i/4 3275 2620 3098 2478 2950 2360 2596 2077
DIG 130 k/4 3608 2886 3413 2730 3250 2600 2860 2288
DIG 142 c/4 4607 3685 4358 3486 4150 3320 3652 2922
DIG 142 d/4 4940 3952 4673 3738 4450 3560 3916 3133
DIG 142 e/4 5439 4351 5145 4116 4900 3920 4312 3450
DIG 150 k/4 5550 4440 5250 4200 5000 4000 4400 3520
DIG 142 f/4 5828 4662 5513 4410 5250 4200 4620 3696
DIG 142 g/4 6216 4973 5880 4704 5600 4480 4928 3942
DIG 150 l/4 6327 5062 5985 4788 5700 4560 5016 4013
DIG 142 h/4 6494 5195 6143 4914 5850 4680 5148 4118
DIG 150 m/4 6660 5328 6300 5040 6000 4800 5280 4224
DIG 150 n/4 6993 5594 6615 5292 6300 5040 5544 4435
DIG 156 l/4 7104 5683 6720 5376 6400 5120 5632 4506
DIG 156 m/4 8436 6749 7980 6384 7600 6080 6688 5350
DIG 156 n/4 9435 7548 8925 7140 8500 6800 7480 5984
Page 19
6 POLE Low Voltage
50Hz/1000rpm
Star 400V
0.8 Power Factor
TEMPERATURE RISE

163/27 150/40 125/40 (H) 105/40 (F) 80/40 (B)
DSG 74 M1/6 814 651 762 610 740 592 636 509 518 414
DSG 74 M2/6 1001 801 937 750 910 728 783 626 637 510
DSG 74 L1/6 1210 968 1133 906 1100 880 946 757 770 616
DSG 74 L2/6 1342 1074 1257 1005 1220 976 1049 839 854 683
DSG 86 K1/6 1650 1320 1545 1236 1500 1200 1365 1092 1200 960
DSG 86 M1/6 1837 1470 1720 1376 1670 1336 1520 1216 1336 1069
DSG 86 L1/6 2101 1681 1967 1574 1910 1528 1738 1390 1528 1222
DSG 99 K0/6 2464 1971 2307 1846 2240 1792 2038 1631 1792 1434
DSG 99 K1/6 2816 2253 2637 2109 2560 2048 2330 1864 2048 1638
DSG 99 M1/6 2970 2376 2781 2225 2700 2160 2457 1966 2160 1728
DSG 99 L1/6 3355 2684 3142 2513 3050 2440 2776 2220 2440 1952
DSG 114 K1/6 3707 2965 3502 2802 3400 2720 3162 2530 2788 2230
DSG 114 M1/6 4393 3515 4151 3321 4030 3224 3748 2998 3305 2644
DSG 114 M2/6 5396 4317 5099 4079 4950 3960 4604 3683 4059 3247
Page 20
6 POLE Low Voltage
50Hz/1000rpm
Star 690V
0.8 Power Factor
TEMPERATURE RISE

163/27 150/40 125/40 (H) 105/40 (F) 80/40 (B)
DSG 74 M1/6 781 625 731 585 710 568 611 488 497 398
DSG 74 M2/6 990 792 927 742 900 720 774 619 630 504
DSG 74 L1/6 1155 924 1082 865 1050 840 903 722 735 588
DSG 86 K1/6 1364 1091 1277 1022 1240 992 1128 903 992 794
DSG 86 M1/6 1705 1364 1597 1277 1550 1240 1411 1128 1240 992
DSG 86 L1/6 2101 1681 1967 1574 1910 1528 1738 1390 1528 1222
DSG 99 K0/6 2255 1804 2112 1689 2050 1640 1866 1492 1640 1312
DSG 99 M1/6 2860 2288 2678 2142 2600 2080 2366 1893 2080 1664
DSG 99 L1/6 3520 2816 3296 2637 3200 2560 2912 2330 2560 2048
DSG 114 K1/6 3816 3053 3605 2884 3500 2800 3255 2604 2870 2296
DSG 114 M2/6 4742 3794 4481 3584 4350 3480 4046 3236 3567 2854
DSG 114 L1/6 5451 4361 5150 4120 5000 4000 4650 3720 4100 3280
Page 21
6 POLE Low Voltage
60Hz/1200rpm
Star 480V
0.8 Power Factor
TEMPERATURE RISE

163/27 150/40 125/40 (H) 105/40 (F) 80/40 (B)
DSG 74 M1/6 979 783 917 733 890 712 765 612 623 498
DSG 74 M2/6 1199 959 1123 898 1090 872 937 750 763 610
DSG 74 L1/6 1452 1162 1360 1088 1320 1056 1135 908 924 739
DSG 74 L2/6 1612 1289 1509 1207 1465 1172 1260 1008 1026 820
DSG 86 K1/6 1980 1584 1854 1483 1800 1440 1638 1310 1440 1152
DSG 86 M1/6 2204 1764 2064 1651 2004 1603 1824 1459 1603 1283
DSG 86 L1/6 2521 2017 2361 1889 2292 1834 2086 1669 1834 1467
DSG 99 K0/6 2957 2365 2769 2215 2688 2150 2446 1957 2150 1720
DSG 99 K1/6 3379 2703 3164 2531 3072 2458 2796 2236 2458 1966
DSG 99 M1/6 3564 2851 3337 2670 3240 2592 2948 2359 2592 2074
DSG 99 L1/6 4026 3221 3770 3016 3660 2928 3331 2664 2928 2342
DSG 114 K1/6 4448 3558 4202 3362 4080 3264 3794 3036 3346 2676
DSG 114 M1/6 5272 4218 4981 3985 4836 3869 4497 3598 3966 3172
DSG 114 M2/6 6476 5181 6118 4895 5940 4752 5524 4419 4871 3897
Page 22
6 POLE Low Voltage
60Hz/1200rpm
Star 600V
0.8 Power Factor
TEMPERATURE RISE

163/27 150/40 125/40 (H) 105/40 (F) 80/40 (B)
DSG 86 K1/6 1483 1186 1388 1111 1348 1078 1227 981 1078 863
DSG 86 M1/6 1827 1462 1711 1369 1661 1329 1511 1209 1329 1063
DSG 99 K0/6 2104 1683 1970 1576 1913 1530 1741 1393 1530 1224
DSG 86 L1/6 2200 1760 2060 1648 2000 1600 1820 1456 1600 1280
DSG 99 K1/6 2391 1913 2239 1791 2174 1739 1978 1583 1739 1391
DSG 99 M1/6 2630 2104 2463 1970 2391 1913 2176 1741 1913 1530
DSG 99 L1/6 3109 2487 2911 2329 2826 2261 2572 2057 2261 1809
DSG 114 K1/6 3460 2768 3269 2615 3174 2539 2952 2361 2603 2082
DSG 114 M1/6 4029 3223 3807 3045 3696 2957 3437 2750 3030 2424
DSG 114 M2/6 4740 3792 4478 3583 4348 3478 4043 3235 3565 2852
DSG 114 L1/6 5593 4474 5284 4227 5130 4104 4771 3817 4207 3366
Page 23
6 POLE Low Voltage
60Hz/1200rpm
Star 690V
0.8 Power Factor
TEMPERATURE RISE

163/27 150/40 125/40 (H) 105/40 (F) 80/40 (B)

DSG 74 M1/6 990 792 927 742 900 720 774 619 630 504
DSG 74 M2/6 1166 933 1092 873 1060 848 912 729 742 594
DSG 74 L1/6 1397 1118 1308 1046 1270 1016 1092 874 889 711
DSG 86 K1/6 1705 1364 1597 1277 1550 1240 1411 1128 1240 992
DSG 86 M1/6 2101 1681 1967 1574 1910 1528 1738 1390 1528 1222
DSG 99 K0/6 2420 1936 2266 1813 2200 1760 2002 1602 1760 1408
DSG 86 L1/6 2530 2024 2369 1895 2300 1840 2093 1674 1840 1472
DSG 99 K1/6 2750 2200 2575 2060 2500 2000 2275 1820 2000 1600
DSG 99 M1/6 3025 2420 2833 2266 2750 2200 2503 2002 2200 1760
DSG 99 L1/6 3575 2860 3348 2678 3250 2600 2958 2366 2600 2080
DSG 114 K1/6 3979 3183 3760 3008 3650 2920 3395 2716 2993 2394
DSG 114 M1/6 4633 3707 4378 3502 4250 3400 3953 3162 3485 2788
DSG 114 M2/6 5451 4361 5150 4120 5000 4000 4650 3720 4100 3280
DSG 114 L1/6 6432 5146 6077 4862 5900 4720 5487 4390 4838 3870
Page 24
6 POLE High Voltage
50Hz/1000rpm
Star 3300V
0.8 Power Factor
TEMPERATURE RISE

138/27 125/40 105/40 (F) 80/40 (B)
DIG 130 h/6 1920 1536 1817 1453 1730 1384 1522 1218
DIG 130 i/6 2276 1820 2153 1722 2050 1640 1804 1443
DIG 130 k/6 2498 1998 2363 1890 2250 1800 1980 1584
DIG 140 h/6 2775 2220 2625 2100 2500 2000 2200 1760
DIG 130 l/6 2942 2353 2783 2226 2650 2120 2332 1866
DIG 140 i/6 3058 2446 2893 2314 2755 2204 2424 1940
DIG 140 k/6 3386 2708 3203 2562 3050 2440 2684 2147
DIG 140 l/6 3719 2975 3518 2814 3350 2680 2948 2358
DIG 140 m/6 4052 3241 3833 3066 3650 2920 3212 2570
DIG 150 k/6 4329 3463 4095 3276 3900 3120 3432 2746
DIG 140 n/6 4496 3596 4253 3402 4050 3240 3564 2851
DIG 150 l/6 5106 4085 4830 3864 4600 3680 4048 3238
DIG 150 m/6 5772 4618 5460 4368 5200 4160 4576 3661
DIG 150 n/6 6105 4884 5775 4620 5500 4400 4840 3872
DIG 156 l/6 6216 4973 5880 4704 5600 4480 4928 3942
DIG 156 m/6 6993 5594 6615 5292 6300 5040 5544 4435
DIG 156 n/6 7548 6038 7140 5712 6800 5440 5984 4787
DIG 156 o/6 8547 6838 8085 6468 7700 6160 6776 5421
DIG 156 p/6 8880 7104 8400 6720 8000 6400 7040 5632
DIG 156 q/6 9435 7548 8925 7140 8500 6800 7480 5984
Page 25
6 POLE High Voltage
50Hz/1000rpm
Star 6300V
0.8 Power Factor
TEMPERATURE RISE

138/27 125/40 105/40 (F) 80/40 (B)
DIG 130 g/6 1610 1288 1523 1218 1450 1160 1276 1021
DIG 130 h/6 1776 1421 1680 1344 1600 1280 1408 1126
DIG 130 i/6 2109 1687 1995 1596 1900 1520 1672 1338
DIG 130 k/6 2442 1954 2310 1848 2200 1760 1936 1549
DIG 140 h/6 2664 2131 2520 2016 2400 1920 2112 1690
DIG 140 i/6 2942 2353 2783 2226 2650 2120 2332 1866
DIG 140 k/6 3330 2664 3150 2520 3000 2400 2640 2112
DIG 140 l/6 3885 3108 3675 2940 3500 2800 3080 2464
DIG 150 k/6 4163 3330 3938 3150 3750 3000 3300 2640
DIG 140 m/6 4218 3374 3990 3192 3800 3040 3344 2675
DIG 150 l/6 4884 3907 4620 3696 4400 3520 3872 3098
DIG 150 m/6 5495 4396 5198 4158 4950 3960 4356 3485
DIG 150 n/6 5828 4662 5513 4410 5250 4200 4620 3696
DIG 156 l/6 6216 4973 5880 4704 5600 4480 4928 3942
DIG 156 m/6 6993 5594 6615 5292 6300 5040 5544 4435
DIG 156 n/6 7548 6038 7140 5712 6800 5440 5984 4787
DIG 156 o/6 8547 6838 8085 6468 7700 6160 6776 5421
DIG 156 p/6 8880 7104 8400 6720 8000 6400 7040 5632
DIG 156 q/6 9435 7548 8925 7140 8500 6800 7480 5984
Page 26
6 POLE High Voltage
50Hz/1000rpm
Star 6600V
0.8 Power Factor
TEMPERATURE RISE

138/27 125/40 105/40 (F) 80/40 (B)
DIG 130 g/6 1610 1288 1523 1218 1450 1160 1276 1021
DIG 130 h/6 1832 1465 1733 1386 1650 1320 1452 1162
DIG 130 i/6 2165 1732 2048 1638 1950 1560 1716 1373
DIG 130 k/6 2498 1998 2363 1890 2250 1800 1980 1584
DIG 140 h/6 2664 2131 2520 2016 2400 1920 2112 1690
DIG 140 i/6 2942 2353 2783 2226 2650 2120 2332 1866
DIG 140 k/6 3330 2664 3150 2520 3000 2400 2640 2112
DIG 140 l/6 3885 3108 3675 2940 3500 2800 3080 2464
DIG 140 m/6 4218 3374 3990 3192 3800 3040 3344 2675
DIG 150 k/6 4329 3463 4095 3276 3900 3120 3432 2746
DIG 150 l/6 5106 4085 4830 3864 4600 3680 4048 3238
DIG 150 m/6 5772 4618 5460 4368 5200 4160 4576 3661
DIG 150 n/6 6105 4884 5775 4620 5500 4400 4840 3872
DIG 156 l/6 6216 4973 5880 4704 5600 4480 4928 3942
DIG 156 m/6 6993 5594 6615 5292 6300 5040 5544 4435
DIG 156 n/6 7548 6038 7140 5712 6800 5440 5984 4787
DIG 156 o/6 8547 6838 8085 6468 7700 6160 6776 5421
DIG 156 p/6 8880 7104 8400 6720 8000 6400 7040 5632
DIG 156 q/6 9435 7548 8925 7140 8500 6800 7480 5984
Page 27
6 POLE High Voltage
50Hz/1000rpm
Star 10500V
0.8 Power Factor
TEMPERATURE RISE

138/27 125/40 105/40 (F) 80/40 (B)
DIG 130 g/6 1499 1199 1418 1134 1350 1080 1188 950
DIG 130 h/6 1721 1376 1628 1302 1550 1240 1364 1091
DIG 130 i/6 2054 1643 1943 1554 1850 1480 1628 1302
DIG 130 k/6 2331 1865 2205 1764 2100 1680 1848 1478
DIG 140 h/6 2442 1954 2310 1848 2200 1760 1936 1549
DIG 130 m/6 2612 2089 2471 1977 2353 1882 2071 1657
DIG 140 i/6 2720 2176 2573 2058 2450 1960 2156 1725
DIG 140 k/6 3108 2486 2940 2352 2800 2240 2464 1971
DIG 140 l/6 3441 2753 3255 2604 3100 2480 2728 2182
DIG 150 k/6 3830 3064 3623 2898 3450 2760 3036 2429
DIG 140 m/6 3885 3108 3675 2940 3500 2800 3080 2464
DIG 150 l/6 4135 3308 3911 3129 3725 2980 3278 2622
DIG 150 m/6 4773 3818 4515 3612 4300 3440 3784 3027
DIG 150 n/6 5217 4174 4935 3948 4700 3760 4136 3309
DIG 156 l/6 6105 4884 5775 4620 5500 4400 4840 3872
DIG 156 m/6 6938 5550 6563 5250 6250 5000 5500 4400
DIG 156 n/6 7382 5905 6983 5586 6650 5320 5852 4682
DIG 156 o/6 7992 6394 7560 6048 7200 5760 6336 5069
DIG 156 p/6 8658 6926 8190 6552 7800 6240 6864 5491
DIG 156 q/6 9435 7548 8925 7140 8500 6800 7480 5984
Page 28
6 POLE High Voltage
50Hz/1000rpm
Star 11000V
0.8 Power Factor
TEMPERATURE RISE

138/27 125/40 105/40 (F) 80/40 (B)
DIG 130 g/6 1499 1199 1418 1134 1350 1080 1188 950
DIG 130 h/6 1721 1376 1628 1302 1550 1240 1364 1091
DIG 130 i/6 2054 1643 1943 1554 1850 1480 1628 1302
DIG 130 k/6 2331 1865 2205 1764 2100 1680 1848 1478
DIG 140 h/6 2442 1954 2310 1848 2200 1760 1936 1549
DIG 130 m/6 2736 2189 2588 2071 2465 1972 2169 1735
DIG 140 i/6 2775 2220 2625 2100 2500 2000 2200 1760
DIG 140 k/6 3053 2442 2888 2310 2750 2200 2420 1936
DIG 140 l/6 3608 2886 3413 2730 3250 2600 2860 2288
DIG 140 m/6 3885 3108 3675 2940 3500 2800 3080 2464
DIG 150 k/6 4052 3241 3833 3066 3650 2920 3212 2570
DIG 150 l/6 4329 3463 4095 3276 3900 3120 3432 2746
DIG 150 m/6 4773 3818 4515 3612 4300 3440 3784 3027
DIG 150 n/6 5495 4396 5198 4158 4950 3960 4356 3485
DIG 156 l/6 6105 4884 5775 4620 5500 4400 4840 3872
DIG 156 m/6 6938 5550 6563 5250 6250 5000 5500 4400
DIG 156 n/6 7382 5905 6983 5586 6650 5320 5852 4682
DIG 156 o/6 7992 6394 7560 6048 7200 5760 6336 5069
DIG 156 p/6 8658 6926 8190 6552 7800 6240 6864 5491
DIG 156 q/6 9435 7548 8925 7140 8500 6800 7480 5984
Page 29
6 POLE High Voltage
60Hz/1200rpm
Star 4160V
0.8 Power Factor
TEMPERATURE RISE

138/27 125/40 105/40 (F) 80/40 (B)
DIG 130 h/6 2220 1776 2100 1680 2000 1600 1760 1408
DIG 130 i/6 2886 2309 2730 2184 2600 2080 2288 1830
DIG 130 k/6 3275 2620 3098 2478 2950 2360 2596 2077
DIG 130 l/6 3663 2930 3465 2772 3300 2640 2904 2323
DIG 150 k/6 4940 3952 4673 3738 4450 3560 3916 3133
DIG 150 l/6 5828 4662 5513 4410 5250 4200 4620 3696
60Hz/1200rpm
Star 6600V
0.8 Power Factor
TEMPERATURE RISE

138/27 125/40 105/40 (F) 80/40 (B)
DIG 130 g/6 1832 1465 1733 1386 1650 1320 1452 1162
DIG 130 h/6 2109 1687 1995 1596 1900 1520 1672 1338
DIG 130 i/6 2442 1954 2310 1848 2200 1760 1936 1549
DIG 130 k/6 2886 2309 2730 2184 2600 2080 2288 1830
DIG 150 k/6 4940 3952 4673 3738 4450 3560 3916 3133
DIG 150 l/6 5828 4662 5513 4410 5250 4200 4620 3696
Page 30
6 POLE High Voltage
60Hz/1200rpm
Star 13800V
0.8 Power Factor
TEMPERATURE RISE

138/27 125/40 105/40 (F) 80/40 (B)
DIG 130 g/6 1776 1421 1680 1344 1600 1280 1408 1126
DIG 130 h/6 2054 1643 1943 1554 1850 1480 1628 1302
DIG 130 i/6 2442 1954 2310 1848 2200 1760 1936 1549
DIG 130 k/6 2831 2264 2678 2142 2550 2040 2244 1795
DIG 150 k/6 4607 3685 4358 3486 4150 3320 3652 2922
DIG 150 l/6 5439 4351 5145 4116 4900 3920 4312 3450
Page 31
8 POLE Low Voltage
50Hz/750rpm
Star 400V
0.8 Power Factor
TEMPERATURE RISE

163/27 150/40 125/40 (H) 105/40 (F) 80/40 (B)
DSG 74 M1/8 682 546 639 511 620 496 533 427 434 347
DSG 74 M2/8 759 607 711 569 690 552 593 475 483 386
DSG 74 L1/8 858 686 803 643 780 624 671 537 546 437
DSG 86 K0/8 990 792 927 742 900 720 819 655 720 576
DSG 74 L2/8 1023 818 958 766 930 744 800 640 651 521
DSG 86 K1/8 1150 920 1076 861 1045 836 951 761 836 669
DSG 86 M1/8 1331 1065 1246 997 1210 968 1101 881 968 774
DSG 86 L1/8 1485 1188 1391 1112 1350 1080 1229 983 1080 864
DSG 99 K1/8 1815 1452 1700 1360 1650 1320 1502 1201 1320 1056
DSG 99 M1/8 2123 1698 1988 1590 1930 1544 1756 1405 1544 1235
DSG 99 L1/8 2486 1989 2328 1862 2260 1808 2057 1645 1808 1446
DSG 99 L2/8 2783 2226 2606 2085 2530 2024 2302 1842 2024 1619
DSG 114 K1/8 3162 2529 2987 2390 2900 2320 2697 2158 2378 1902
DSG 114 M1/8 3630 2904 3430 2744 3330 2664 3097 2478 2731 2184
DSG 114 L1/8 4393 3515 4151 3321 4030 3224 3748 2998 3305 2644
Page 32
8 POLE Low Voltage
50Hz/750rpm
Star 690V
0.8 Power Factor
TEMPERATURE RISE

163/27 150/40 125/40 (H) 105/40 (F) 80/40 (B)
DSG 74 M1/8 660 528 618 494 600 480 516 413 420 336
DSG 74 M2/8 759 607 711 569 690 552 593 475 483 386
DSG 74 L1/8 880 704 824 659 800 640 688 550 560 448
DSG 74 L2/8 946 757 886 709 860 688 740 592 602 482
DSG 86 K0/8 990 792 927 742 900 720 819 655 720 576
DSG 86 K1/8 1100 880 1030 824 1000 800 910 728 800 640
DSG 86 M1/8 1331 1065 1246 997 1210 968 1101 881 968 774
DSG 86 L1/8 1573 1258 1473 1178 1430 1144 1301 1041 1144 915
DSG 99 K1/8 1815 1452 1700 1360 1650 1320 1502 1201 1320 1056
DSG 99 M1/8 2123 1698 1988 1590 1930 1544 1756 1405 1544 1235
DSG 99 L1/8 2486 1989 2328 1862 2260 1808 2057 1645 1808 1446
DSG 114 K1/8 2616 2093 2472 1978 2400 1920 2232 1786 1968 1574
DSG 99 L2/8 2783 2226 2606 2085 2530 2024 2302 1842 2024 1619
DSG 114 M1/8 2943 2355 2781 2225 2700 2160 2511 2009 2214 1771
DSG 114 M2/8 3347 2677 3162 2530 3070 2456 2855 2284 2517 2014
DSG 114 L2/8 4143 3314 3914 3131 3800 3040 3534 2827 3116 2493
DSG 125 K2/8 4906 3925 4635 3708 4500 3600 4185 3348 3690 2952
DSG 125 M1/8 5832 4666 5511 4408 5350 4280 4976 3980 4387 3510
DSG 125 M2/8 6650 5320 6283 5026 6100 4880 5673 4538 5002 4002
DSG 125 L1/8 7631 6105 7210 5768 7000 5600 6510 5208 5740 4592
Page 33
8 POLE Low Voltage
60Hz/900rpm
Star 480V
0.8 Power Factor
TEMPERATURE RISE

163/27 150/40 125/40 (H) 105/40 (F) 80/40 (B)
DSG 74 M1/8 820 656 767 614 745 596 641 513 522 417
DSG 74 M2/8 913 730 855 684 830 664 714 571 581 465
DSG 74 L1/8 1029 823 963 770 935 748 804 643 655 524
DSG 74 L2/8 1227 981 1148 919 1115 892 959 767 781 624
DSG 86 K0/8 1366 1093 1279 1023 1242 994 1130 904 994 795
DSG 86 K1/8 1586 1269 1485 1188 1442 1154 1312 1050 1154 923
DSG 86 M1/8 1782 1426 1669 1335 1620 1296 1474 1179 1296 1037
DSG 86 L1/8 1958 1566 1833 1467 1780 1424 1620 1296 1424 1139
DSG 99 K1/8 2288 1830 2142 1714 2080 1664 1893 1514 1664 1331
DSG 99 M1/8 2673 2138 2503 2002 2430 1944 2211 1769 1944 1555
DSG 99 L1/8 3135 2508 2936 2348 2850 2280 2594 2075 2280 1824
DSG 99 L2/8 3509 2807 3286 2629 3190 2552 2903 2322 2552 2042
DSG 114 K1/8 3794 3035 3584 2868 3480 2784 3236 2589 2854 2283
DSG 114 M1/8 4356 3485 4116 3293 3996 3197 3716 2973 3277 2621
DSG 114 L1/8 5272 4218 4981 3985 4836 3869 4497 3598 3966 3172
Page 34
8 POLE Low Voltage
60Hz/900rpm
Star 600V
0.8 Power Factor
TEMPERATURE RISE

163/27 150/40 125/40 (H) 105/40 (F) 80/40 (B)
DSG 86 K0/8 1033 826 967 774 939 751 855 684 751 601
DSG 99 L2/8 2850 2280 2669 2135 2591 2073 2358 1886 2073 1658
DSG 114 K1/8 3413 2730 3224 2579 3130 2504 2911 2329 2567 2054
DSG 114 M1/8 3934 3147 3717 2974 3609 2887 3356 2685 2959 2367
DSG 114 M2/8 4091 3272 3865 3092 3752 3002 3490 2792 3077 2461
DSG 114 L1/8 4683 3746 4425 3540 4296 3437 3995 3196 3522 2818
Page 35
8 POLE Low Voltage
60Hz/900rpm
Star 690V
0.8 Power Factor
TEMPERATURE RISE

163/27 150/40 125/40 (H) 105/40 (F) 80/40 (B)
DSG 74 M1/8 759 607 711 569 690 552 593 475 483 386
DSG 74 M2/8 880 704 824 659 800 640 688 550 560 448
DSG 74 L1/8 946 757 886 709 860 688 740 592 602 482
DSG 74 L2/8 1155 924 1082 865 1050 840 903 722 735 588
DSG 86 K0/8 1188 950 1112 890 1080 864 983 786 864 691
DSG 86 K1/8 1320 1056 1236 989 1200 960 1092 874 960 768
DSG 86 M1/8 1595 1276 1494 1195 1450 1160 1320 1056 1160 928
DSG 86 L1/8 1815 1452 1700 1360 1650 1320 1502 1201 1320 1056
DSG 99 K1/8 2178 1742 2039 1632 1980 1584 1802 1441 1584 1267
DSG 99 M1/8 2442 1954 2287 1829 2220 1776 2020 1616 1776 1421
DSG 99 L1/8 2937 2350 2750 2200 2670 2136 2430 1944 2136 1709
DSG 99 L2/8 3278 2622 3069 2456 2980 2384 2712 2169 2384 1907
DSG 114 K1/8 3925 3140 3708 2966 3600 2880 3348 2678 2952 2362
DSG 114 M1/8 4524 3619 4275 3420 4150 3320 3860 3088 3403 2722
DSG 114 M2/8 4704 3763 4444 3556 4315 3452 4013 3210 3538 2831
DSG 114 L1/8 5385 4308 5088 4071 4940 3952 4594 3675 4051 3241
DSG 125 K2/8 5832 4666 5511 4408 5350 4280 4976 3980 4387 3510
DSG 125 M1/8 6650 5320 6283 5026 6100 4880 5673 4538 5002 4002
DSG 125 M2/8 7631 6105 7210 5768 7000 5600 6510 5208 5740 4592
DSG 125 L1/8 9267 7413 8755 7004 8500 6800 7905 6324 6970 5576
Page 36
8 POLE High Voltage
50Hz/750rpm
Star 3300V
0.8 Power Factor
TEMPERATURE RISE

138/27 125/40 105/40 (F) 80/40 (B)
DIG 130 i/8 1650 1320 1561 1249 1487 1189 1308 1047
DIG 150 k/8 3219 2575 3045 2436 2900 2320 2552 2042
DIG 150 l/8 3663 2930 3465 2772 3300 2640 2904 2323
DIG 150 m/8 4107 3286 3885 3108 3700 2960 3256 2605
DIG 150 n/8 4551 3641 4305 3444 4100 3280 3608 2886
DIG 156 k/8 4662 3730 4410 3528 4200 3360 3696 2957
DIG 156 l/8 5217 4174 4935 3948 4700 3760 4136 3309
DIG 150 o/8 5328 4262 5040 4032 4800 3840 4224 3379
DIG 156 m/8 5661 4529 5355 4284 5100 4080 4488 3590
DIG 156 n/8 6327 5062 5985 4788 5700 4560 5016 4013
DIG 156 o/8 7104 5683 6720 5376 6400 5120 5632 4506
DIG 156 p/8 7548 6038 7140 5712 6800 5440 5984 4787
Page 37
8 POLE High Voltage
50Hz/750rpm
Star 6300V
0.8 Power Factor
TEMPERATURE RISE

138/27 125/40 105/40 (F) 80/40 (B)
DIG 150 k/8 3219 2575 3045 2436 2900 2320 2552 2042
DIG 150 l/8 3441 2753 3255 2604 3100 2480 2728 2182
DIG 150 m/8 3830 3064 3623 2898 3450 2760 3036 2429
DIG 150 n/8 4329 3463 4095 3276 3900 3120 3432 2746
DIG 156 k/8 4662 3730 4410 3528 4200 3360 3696 2957
DIG 150 o/8 5106 4085 4830 3864 4600 3680 4048 3238
DIG 156 l/8 5217 4174 4935 3948 4700 3760 4136 3309
DIG 156 m/8 5772 4618 5460 4368 5200 4160 4576 3661
DIG 156 n/8 6050 4840 5723 4578 5450 4360 4796 3837
DIG 156 o/8 7104 5683 6720 5376 6400 5120 5632 4506
DIG 156 p/8 7326 5861 6930 5544 6600 5280 5808 4646
Page 38
8 POLE High Voltage
50Hz/750rpm
Star 6600V
0.8 Power Factor
TEMPERATURE RISE

138/27 125/40 105/40 (F) 80/40 (B)
DIG 130 h/8 1388 1110 1301 1041 1239 991 1090 872
DIG 130 l/8 2109 1687 1977 1582 1883 1506 1657 1326
DIG 150 k/8 3108 2486 2940 2352 2800 2240 2464 1971
DIG 150 l/8 3552 2842 3360 2688 3200 2560 2816 2253
DIG 150 m/8 4052 3241 3833 3066 3650 2920 3212 2570
DIG 150 n/8 4551 3641 4305 3444 4100 3280 3608 2886
DIG 156 k/8 4662 3730 4410 3528 4200 3360 3696 2957
DIG 156 l/8 5217 4174 4935 3948 4700 3760 4136 3309
DIG 150 o/8 5328 4262 5040 4032 4800 3840 4224 3379
DIG 156 m/8 5772 4618 5460 4368 5200 4160 4576 3661
DIG 156 n/8 6327 5062 5985 4788 5700 4560 5016 4013
DIG 156 o/8 7104 5683 6720 5376 6400 5120 5632 4506
DIG 156 p/8 7326 5861 6930 5544 6600 5280 5808 4646
Page 39
8 POLE High Voltage
50Hz/750rpm
Star 10500V
0.8 Power Factor
TEMPERATURE RISE

138/27 125/40 105/40 (F) 80/40 (B)
DIG 150 k/8 3164 2531 2993 2394 2850 2280 2508 2006
DIG 150 l/8 3663 2930 3465 2772 3300 2640 2904 2323
DIG 150 m/8 4052 3241 3833 3066 3650 2920 3212 2570
DIG 150 n/8 4440 3552 4200 3360 4000 3200 3520 2816
DIG 156 k/8 4662 3730 4410 3528 4200 3360 3696 2957
DIG 150 o/8 4773 3818 4515 3612 4300 3440 3784 3027
DIG 156 l/8 4884 3907 4620 3696 4400 3520 3872 3098
DIG 156 m/8 5550 4440 5250 4200 5000 4000 4400 3520
DIG 156 n/8 6327 5062 5985 4788 5700 4560 5016 4013
DIG 156 o/8 6660 5328 6300 5040 6000 4800 5280 4224
DIG 156 p/8 7437 5950 7035 5628 6700 5360 5896 4717
50Hz/750rpm
Star 11000V
0.8 Power Factor
TEMPERATURE RISE

138/27 125/40 105/40 (F) 80/40 (B)
DIG 150 k/8 3164 2531 2993 2394 2850 2280 2508 2006
DIG 150 l/8 3663 2930 3465 2772 3300 2640 2904 2323
DIG 150 m/8 4274 3419 4043 3234 3850 3080 3388 2710
DIG 150 n/8 4440 3552 4200 3360 4000 3200 3520 2816
DIG 156 k/8 4662 3730 4410 3528 4200 3360 3696 2957
DIG 150 o/8 4995 3996 4725 3780 4500 3600 3960 3168
DIG 156 l/8 5162 4129 4883 3906 4650 3720 4092 3274
DIG 156 m/8 5772 4618 5460 4368 5200 4160 4576 3661
DIG 156 n/8 6216 4973 5880 4704 5600 4480 4928 3942
DIG 156 o/8 6660 5328 6300 5040 6000 4800 5280 4224
DIG 156 p/8 7437 5950 7035 5628 6700 5360 5896 4717
Page 40
8 POLE High Voltage
60Hz/900rpm
Star 4160V
0.8 Power Factor
TEMPERATURE RISE

138/27 125/40 105/40 (F) 80/40 (B)
DIG 150 k/8 4218 3374 3990 3192 3800 3040 3344 2675
DIG 150 l/8 4662 3730 4410 3528 4200 3360 3696 2957
DIG 150 m/8 5106 4085 4830 3864 4600 3680 4048 3238
DIG 156 k/8 5439 4351 5145 4116 4900 3920 4312 3450
DIG 150 n/8 5550 4440 5250 4200 5000 4000 4400 3520
DIG 150 o/8 5994 4795 5670 4536 5400 4320 4752 3802
DIG 156 l/8 5994 4795 5670 4536 5400 4320 4752 3802
DIG 156 m/8 6549 5239 6195 4956 5900 4720 5192 4154
DIG 156 n/8 7104 5683 6720 5376 6400 5120 5632 4506
DIG 156 o/8 7937 6349 7508 6006 7150 5720 6292 5034
60Hz/900rpm
Star 6600V
0.8 Power Factor
TEMPERATURE RISE

138/27 125/40 105/40 (F) 80/40 (B)
DIG 150 k/8 3497 2797 3308 2646 3150 2520 2772 2218
DIG 150 l/8 3996 3197 3780 3024 3600 2880 3168 2534
DIG 150 m/8 4551 3641 4305 3444 4100 3280 3608 2886
DIG 150 n/8 5273 4218 4988 3990 4750 3800 4180 3344
DIG 156 k/8 5550 4440 5250 4200 5000 4000 4400 3520
DIG 150 o/8 5994 4795 5670 4536 5400 4320 4752 3802
DIG 156 l/8 6105 4884 5775 4620 5500 4400 4840 3872
DIG 156 m/8 6882 5506 6510 5208 6200 4960 5456 4365
DIG 156 n/8 7548 6038 7140 5712 6800 5440 5984 4787
DIG 156 o/8 8325 6660 7875 6300 7500 6000 6600 5280
Page 41
8 POLE High Voltage
60Hz/900rpm
Star 13800V
0.8 Power Factor
TEMPERATURE RISE

138/27 125/40 105/40 (F) 80/40 (B)
DIG 150 k/8 3663 2930 3465 2772 3300 2640 2904 2323
DIG 150 l/8 4218 3374 3990 3192 3800 3040 3344 2675
DIG 150 m/8 4662 3730 4410 3528 4200 3360 3696 2957
DIG 150 n/8 5106 4085 4830 3864 4600 3680 4048 3238
DIG 156 k/8 5217 4174 4935 3948 4700 3760 4136 3309
DIG 156 l/8 5772 4618 5460 4368 5200 4160 4576 3661
DIG 156 m/8 6438 5150 6090 4872 5800 4640 5104 4083
DIG 156 n/8 7271 5816 6878 5502 6550 5240 5764 4611
DIG 156 o/8 7770 6216 7350 5880 7000 5600 6160 4928
Page 42
10 POLE Low Voltage
50Hz/600rpm
Star 400V
0.8 Power Factor
TEMPERATURE RISE

163/27 150/40 125/40 (H) 105/40 (F) 80/40 (B)
DSG 86 K0/10 737 590 690 552 670 536 610 488 536 429
DSG 86 K1/10 902 722 845 676 820 656 746 597 656 525
DSG 86 M1/10 1051 840 984 787 955 764 869 695 764 611
DSG 86 L1/10 1221 977 1143 915 1110 888 1010 808 888 710
DSG 99 K1/10 1342 1074 1257 1005 1220 976 1110 888 976 781
DSG 99 M1/10 1562 1250 1463 1170 1420 1136 1292 1034 1136 909
DSG 99 L1/10 1771 1417 1658 1327 1610 1288 1465 1172 1288 1030
DSG 99 L2/10 2013 1610 1885 1508 1830 1464 1665 1332 1464 1171
DSG 114 K1/10 2344 1875 2215 1772 2150 1720 2000 1600 1763 1410
DSG 114 M1/10 2578 2063 2436 1949 2365 1892 2199 1760 1939 1551
DSG 114 M2/10 2987 2390 2822 2258 2740 2192 2548 2039 2247 1797
DSG 114 L1/10 3401 2721 3214 2571 3120 2496 2902 2321 2558 2047
Page 43
10 POLE Low Voltage
50Hz/600rpm
Star 690V
0.8 Power Factor
TEMPERATURE RISE

163/27 150/40 125/40 (H) 105/40 (F) 80/40 (B)
DSG 86 K0/10 792 634 742 593 720 576 655 524 576 461
DSG 86 K1/10 902 722 845 676 820 656 746 597 656 525
DSG 86 M1/10 1051 840 984 787 955 764 869 695 764 611
DSG 86 L1/10 1221 977 1143 915 1110 888 1010 808 888 710
DSG 99 K1/10 1342 1074 1257 1005 1220 976 1110 888 976 781
DSG 99 M1/10 1562 1250 1463 1170 1420 1136 1292 1034 1136 909
DSG 99 L1/10 1925 1540 1803 1442 1750 1400 1593 1274 1400 1120
DSG 99 L2/10 2200 1760 2060 1648 2000 1600 1820 1456 1600 1280
DSG 114 K1/10 2268 1814 2142 1714 2080 1664 1934 1548 1706 1364
DSG 114 M1/10 2616 2093 2472 1978 2400 1920 2232 1786 1968 1574
DSG 114 M2/10 2998 2398 2833 2266 2750 2200 2558 2046 2255 1804
DSG 114 L1/10 3543 2834 3348 2678 3250 2600 3023 2418 2665 2132
Page 44
10 POLE Low Voltage
60Hz/720rpm
Star 480V
0.8 Power Factor
TEMPERATURE RISE

163/27 150/40 125/40 (H) 105/40 (F) 80/40 (B)
DSG 86 K0/10 884 708 828 662 804 643 732 585 643 515
DSG 86 K1/10 1082 866 1014 811 984 787 895 716 787 630
DSG 86 M1/10 1261 1008 1180 944 1146 917 1043 834 917 733
DSG 86 L1/10 1465 1172 1372 1098 1332 1066 1212 970 1066 852
DSG 99 K1/10 1610 1288 1508 1206 1464 1171 1332 1066 1171 937
DSG 99 M1/10 1874 1500 1755 1404 1704 1363 1551 1241 1363 1091
DSG 99 L1/10 2125 1700 1990 1592 1932 1546 1758 1406 1546 1236
DSG 99 L2/10 2416 1932 2262 1810 2196 1757 1998 1599 1757 1405
DSG 114 K1/10 2813 2250 2657 2126 2580 2064 2399 1920 2116 1692
DSG 114 M1/10 3094 2475 2923 2339 2838 2270 2639 2111 2327 1862
DSG 114 M2/10 3585 2868 3387 2709 3288 2630 3058 2446 2696 2157
DSG 114 L1/10 4082 3265 3856 3085 3744 2995 3482 2786 3070 2456
Page 45
10 POLE Low Voltage
60Hz/720rpm
Star 690V
0.8 Power Factor
TEMPERATURE RISE

163/27 150/40 125/40 (H) 105/40 (F) 80/40 (B)
DSG 86 K0/10 902 722 845 676 820 656 746 597 656 525
DSG 86 K1/10 1045 836 979 783 950 760 865 692 760 608
DSG 86 M1/10 1265 1012 1185 948 1150 920 1047 837 920 736
DSG 86 L1/10 1430 1144 1339 1071 1300 1040 1183 946 1040 832
DSG 99 K1/10 1562 1250 1463 1170 1420 1136 1292 1034 1136 909
DSG 99 M1/10 1925 1540 1803 1442 1750 1400 1593 1274 1400 1120
DSG 99 L1/10 2200 1760 2060 1648 2000 1600 1820 1456 1600 1280
DSG 114 K1/10 2616 2093 2472 1978 2400 1920 2232 1786 1968 1574
DSG 114 M1/10 2998 2398 2833 2266 2750 2200 2558 2046 2255 1804
DSG 114 M2/10 3543 2834 3348 2678 3250 2600 3023 2418 2665 2132
DSG 114 L1/10 3925 3140 3708 2966 3600 2880 3348 2678 2952 2362
DSG 125 K1/10 4579 3663 4326 3461 4200 3360 3906 3125 3444 2755
DSG 125 M1/10 5233 4186 4944 3955 4800 3840 4464 3571 3936 3149
DSG 125 M2/10 5669 4535 5356 4285 5200 4160 4836 3869 4264 3411
DSG 125 L1/10 6269 5015 5923 4738 5750 4600 5348 4278 4715 3772
DSG 144 M1/10 7195 5756 6798 5438 6600 5280 6138 4910 5412 4330
Page 46
10 POLE High Voltage
50Hz/600rpm
Star 3300V
0.8 Power Factor
TEMPERATURE RISE

138/27 125/40 105/40 (F) 80/40 (B)
DIG 156 k/10 3830 3064 3623 2898 3450 2760 3036 2429
DIG 156 l/10 4496 3596 4253 3402 4050 3240 3564 2851
DIG 156 m/10 4662 3730 4410 3528 4200 3360 3696 2957
DIG 156 n/10 5106 4085 4830 3864 4600 3680 4048 3238
DIG 156 o/10 5550 4440 5250 4200 5000 4000 4400 3520
DIG 156 p/10 6749 5399 6384 5107 6080 4864 5350 4280
DIG 156 q/10 7604 6083 7193 5754 6850 5480 6028 4822
50Hz/600rpm
Star 6300V
0.8 Power Factor
TEMPERATURE RISE

138/27 125/40 105/40 (F) 80/40 (B)
DIG 156 k/10 3941 3152 3728 2982 3550 2840 3124 2499
DIG 156 l/10 4218 3374 3990 3192 3800 3040 3344 2675
DIG 156 m/10 4662 3730 4410 3528 4200 3360 3696 2957
DIG 156 n/10 5106 4085 4830 3864 4600 3680 4048 3238
DIG 156 o/10 5550 4440 5250 4200 5000 4000 4400 3520
DIG 156 p/10 5994 4795 5670 4536 5400 4320 4752 3802
DIG 156 q/10 6549 5239 6195 4956 5900 4720 5192 4154
Page 47
50Hz/600rpm
Star 6600V
0.8 Power Factor
TEMPERATURE RISE

138/27 125/40 105/40 (F) 80/40 (B)

DIG 156 k/10 3941 3152 3728 2982 3550 2840 3124 2499
DIG 156 l/10 4329 3463 4095 3276 3900 3120 3432 2746
DIG 156 m/10 4662 3730 4410 3528 4200 3360 3696 2957
DIG 156 n/10 5106 4085 4830 3864 4600 3680 4048 3238
DIG 156 o/10 5550 4440 5250 4200 5000 4000 4400 3520
DIG 156 p/10 5994 4795 5670 4536 5400 4320 4752 3802
DIG 156 q/10 6549 5239 6195 4956 5900 4720 5192 4154
50Hz/600rpm
Star 10500V
0.8 Power Factor
TEMPERATURE RISE

138/27 125/40 105/40 (F) 80/40 (B)
DIG 156 k/10 3441 2753 3255 2604 3100 2480 2728 2182
DIG 156 l/10 4107 3286 3885 3108 3700 2960 3256 2605
DIG 156 m/10 4440 3552 4200 3360 4000 3200 3520 2816
DIG 156 n/10 4995 3996 4725 3780 4500 3600 3960 3168
DIG 156 o/10 5439 4351 5145 4116 4900 3920 4312 3450
DIG 156 p/10 5772 4618 5460 4368 5200 4160 4576 3661
DIG 156 q/10 6105 4884 5775 4620 5500 4400 4840 3872
Page 48
50Hz/600rpm
Star 11000V
0.8 Power Factor
TEMPERATURE RISE

138/27 125/40 105/40 (F) 80/40 (B)
DIG 156 k/10 3441 2753 3255 2604 3100 2480 2728 2182
DIG 156 l/10 3941 3152 3728 2982 3550 2840 3124 2499
DIG 156 m/10 4329 3463 4095 3276 3900 3120 3432 2746
DIG 156 n/10 4995 3996 4725 3780 4500 3600 3960 3168
DIG 156 o/10 5217 4174 4935 3948 4700 3760 4136 3309
DIG 156 p/10 5772 4618 5460 4368 5200 4160 4576 3661
DIG 156 q/10 6327 5062 5985 4788 5700 4560 5016 4013
60Hz/720rpm
Star 4160V
0.8 Power Factor
TEMPERATURE RISE

138/27 125/40 105/40 (F) 80/40 (B)
DIG 156 k/10 5106 4085 4830 3864 4600 3680 4048 3238
DIG 156 l/10 5550 4440 5250 4200 5000 4000 4400 3520
DIG 156 m/10 5994 4795 5670 4536 5400 4320 4752 3802
DIG 156 n/10 6438 5150 6090 4872 5800 4640 5104 4083
DIG 156 o/10 7104 5683 6720 5376 6400 5120 5632 4506
DIG 156 p/10 8048 6438 7613 6090 7250 5800 6380 5104
DIG 156 q/10 8492 6793 8033 6426 7650 6120 6732 5386
Page 49
60Hz/720rpm
Star 6600V
0.8 Power Factor
TEMPERATURE RISE

138/27 125/40 105/40 (F) 80/40 (B)
DIG 156 k/10 4551 3641 4305 3444 4100 3280 3608 2886
DIG 156 m/10 5051 4040 4778 3822 4550 3640 4004 3203
DIG 156 l/10 5217 4174 4935 3948 4700 3760 4136 3309
DIG 156 n/10 6216 4973 5880 4704 5600 4480 4928 3942
DIG 156 o/10 6216 4973 5880 4704 5600 4480 4928 3942
DIG 156 p/10 6882 5506 6510 5208 6200 4960 5456 4365
DIG 156 q/10 7770 6216 7350 5880 7000 5600 6160 4928
60Hz/720rpm
Star 13800V
0.8 Power Factor
TEMPERATURE RISE

138/27 125/40 105/40 (F) 80/40 (B)
DIG 156 k/10 2986 2389 2825 2260 2690 2152 2367 1894
DIG 156 l/10 3585 2868 3392 2713 3230 2584 2842 2274
DIG 156 m/10 3996 3197 3780 3024 3600 2880 3168 2534
DIG 156 n/10 4473 3579 4232 3385 4030 3224 3546 2837
DIG 156 o/10 4473 3579 4232 3385 4030 3224 3546 2837
DIG 156 p/10 5051 4040 4778 3822 4550 3640 4004 3203
DIG 156 q/10 5051 4040 4778 3822 4550 3640 4004 3203
Page 50
Application Engineering
Application Engineering generally owns the technical ■■ Discuss needs, resolve issues and review
relationship with our customers and therefore is the specification
first point of contact. The team’s aim is to ‘Delight –– Provide qualified technical recommendations to
our Customers’ by providing a world class customer ensure fit for purpose products
service by striving to understand customer needs –– Assist with design and development of
and best matched products to suit each individual complete generating set systems
customer application.
■■ Provide bespoke application engineering training
to suit customer requirements
Application teams are based in the US, Europe,
India and China, sharing a common email –– Application sizing
enquiry database. Due to this, there are always –– Alternator selection considerations
Application Engineers available to support customer
–– Changing market requirements such as grid
requirements and deliver the best technical product codes or marine standards
selection that STAMFORD I AvK branded products
can offer.
■■ Provide Voice of Customer and application field
knowledge into new product introduction or
Key deliverables include: product improvement programs.
Application Engineering support customers as they

■■ Provide technical data and support for Cummins
venture into new market segments and integrate
Generator Technologies products
product designs to ensure superior fit to market. The
–– Technical data, drawings, application guidance team work closely with the Application Validation
notes
Team to validate and fully understand the operating
–– Size alternators for different load applications boundaries of our products to ensure the right
-motors, lighting, non-linear (UPS, VSD, SCR) machines meet the harsh, increasingly challenging
–– Advise and discuss all aspects of alternator environments in which our customers operate in.
application, control and installation
For Applications Support contact:

applications@cummins.com
Page 51
Follow us @stamfordavk
Cummins Generator Technologies
youtube.com/stamfordavk
news.stamford-avk.com
For Applications Support:

applications@cummins.com
For Customer Service:
service-engineers@cumminsgeneratortechnologies.com
For general enquiries:
stamford-avk@cummins.com
Copyright 2017, Cummins Generator Technologies Ltd. All rights reserved.
Cummins and the Cummins logo are registered trade marks of Cummins Inc.
STAMFORD, AvK are registered trade marks of Cummins Generator Technologies Ltd.
Part No. A056R161 Rev. 02
Disclaimer
The ratings provided are for information only, the accuracy cannot be guaranteed as Cummins Generator Technologies has
an ongoing process of development and reserves the right to change the contents of ratings book without notice and
shall not be held responsible for any subsequent claims in relation to the content

AvK Industrial Ratings Book 2

Uploaded by

Copyright:

Available Formats

AvK Industrial Ratings Book 2

Uploaded by

Document Information

Original Description:

Copyright

Available Formats

Share this document

Share or Embed Document

Sharing Options

Did you find this document useful?

Is this content inappropriate?

Copyright:

Available Formats

AvK Industrial Ratings Book 2

Uploaded by

Copyright:

Available Formats

Alternator

Generator Set Ratings

Emergency Standby Continuous

Load type Variable Constant Variable Constant

Average load 70% 100% 70% 100%

Class H 125/40 Class H 125/40

Temperature ºC Multiplying Factor Multiplying Factor Multiplying Factor

50 0.935 0.925 0.910

55 0.903 0.888 0.865

60 0.870 0.850 0.820

For ambient temperatures above 60 ºC please consult applications engineering.

Altitude (Low Voltage ≤ 690V)

Please consult applications engineering department for

4 POLE low Voltage Page

4 POLE High Voltage Page

6 POLE low Voltage Page

6 POLE High Voltage Page

8 POLE low Voltage Page

8 POLE High Voltage Page

10 POLE low Voltage Page

10 POLE High Voltage Page

4 POLE Low Voltage

Standby Standby Continuous Continuous Continuous

Model kVA kW kVA kW kVA kW kVA kW kVA kW

4 POLE Low Voltage

Standby Standby Continuous Continuous Continuous

Model kVA kW kVA kW kVA kW kVA kW kVA kW

4 POLE Low Voltage

Standby Standby Continuous Continuous Continuous

Model kVA kW kVA kW kVA kW kVA kW kVA kW

Standby Standby Continuous Continuous Continuous

Model kVA kW kVA kW kVA kW kVA kW kVA kW

4 POLE Low Voltage

Standby Standby Continuous Continuous Continuous

Model kVA kW kVA kW kVA kW kVA kW kVA kW

4 POLE High Voltage

Standby Standby Continuous Continuous

Model kVA kW kVA kW kVA kW kVA kW

4 POLE High Voltage

Standby Standby Continuous Continuous

Model kVA kW kVA kW kVA kW kVA kW

4 POLE High Voltage

Standby Standby Continuous Continuous

Model kVA kW kVA kW kVA kW kVA kW

4 POLE High Voltage

Standby Standby Continuous Continuous

Model kVA kW kVA kW kVA kW kVA kW

4 POLE High Voltage

Standby Standby Continuous Continuous

Model kVA kW kVA kW kVA kW kVA kW

4 POLE High Voltage

Standby Standby Continuous Continuous

Model kVA kW kVA kW kVA kW kVA kW

4 POLE High Voltage

Standby Standby Continuous Continuous

Model kVA kW kVA kW kVA kW kVA kW

4 POLE High Voltage

Standby Standby Continuous Continuous

Model kVA kW kVA kW kVA kW kVA kW