RELEASE REV

REVISION DESCRIPTION BY DATE APPD

NUMBER LTR
P35964-02 - INITIAL RELEASE RWE 10/23/09 GAP
P42483-02 A 1:ADDED ITEM 2. HAE 04/25/12 GAP
2:ADDED 06-75158-001.

1 1 - PHOPHT90218481 CHM,FULL,V4.20,HW 2.A0,M2 2

- 1 PHOPHT90206502 BULKHEAD MODULE-FULL,SOFTWARE 1
QTY QTY ITEM NUMBER PART DESCRIPTION REF
Daimler Trucks
North America
ELEC INTERFC-CHASSIS MODULE
MDL-CHM,FULL,V4.20,HW 2.A0

THE INFORMATION CONTAINED HEREIN IS PROPRIETARY DATA, AND IS NOT FOR DISSEMINATION OR DISCLOSURE,
IN WHOLE OR IN PART, FOR ANY PURPOSE OTHER THAN THAT FOR WHICH IT ISSUBMITTED, EXCEPT AS
AUTHORIZED IN WRITING BY DAIMLER TRUCKS NORTH AMERICA LLC (DTNA)
MATERIAL APPROVAL DATE
06-75158-001

06-75158-000

N/A N/A UNLESS OTHERWISE NOTED, DIMENSIONS AND

DRAWN BY DATE TOLERANCESARE DEFINED ACCORDING TO
DELIVERY MUST CONFORM R.ERKER 10/22/09 ASME Y14.5M- 1994,WITH EXCEPTION PER
EXACTLY WITH DRAWING CHECKED BY DATE DTNA 09ENG-WI037
SPECIFICATIONS AND, WHERE K.MILLER 10/22/09
RESPONSIBLE ENGINEER DATE
REQUIRED BY Q.A., WITH APPROVED THIRD UNITS OF
M.DOAN 10/22/09 MEASURE
Q.A. SAMPLES. ABSOLUTELY NO APPROVED BY DATE
ANGLE
PROJECTION MM
CHANGES ARE PERMITTED WITHOUT G.PITTMAN 10/22/09
PRIOR APPROVAL BY DTNA. THIS DESCRIPTION

INCLUDES CHANGES TO: ELEC INTFC-CHASSIS MODULE

SOFTWARE, MATERIALS, INTERNAL SUPPLEMENTAL DESCRIPTION
DESCRIPTION
ITEM NUMBER

ITEM NUMBER

DESCRIPTION

COMPONENTS, MANUFACTURING 32K03 M2

PROCESSES. ITEM/DRAWING NUMBER REVISION LETTER PAGE

06-75158 A 1 of 9
 1. IDENTIFY COMPONENT PER DTNA SPEC 49-00051.

2. THIS MODULE MUST MEET DTNA PERFORMANCE REQUIREMENTS

STANDARD 49-00085 FOR ELECTRICAL / ELECTRONICS MODULES.

3. SIGNAL DESCRIPTIONS & ASSOCIATED CURRENTS ARE REFERENCE ONLY

UNLESS MODULE IS USED AS A CHASSIS INSTEAD OF EXPANSION MODULE.

4 COMMON NODE PINS:

C1-A,C1-H,C1-J (TOTAL CURRENT POTENTIAL ON THIS NODE 6.7AMPS OR LESS)
C1-D,C1-E,C1-F,C2-G,C3-P (PASS THROUGH. IN @ C3-P, OUT @ C1-D,E,F & C2-G)
C1-G,C2-H,C3-N (TOTAL CURRENT POTENTIAL ON THIS NODE 6.7AMPS OR LESS)
C1-P,C2-E,C3-R (TOTAL CURRENT POTENTIAL ON THIS NODE 6.7AMPS OR LESS)
C3-C,C3-D (TOTAL CURRENT POTENTIAL ON THIS NODE 6.7AMPS OR LESS)
C2-F,C4-C,C4-D,C4-L,C4-M (TOTAL CURRENT ON THIS NODE MUST BE 25AMPS OR LESS)
C2-D,C3-G (GROUND INPU

5. "DI" DIGITAL INPUTS ARE GROUND ACTIVATED INPUTS UNLESS OTHERWISE NOTED.
IF "WK UP" IS INCLUDED IN TYPE COLUMN, THAT INPUT WILL WAKE UP THE
MULTIPLEX DEVICES IN THE SYSTEM WHEN ACTIVE.

6 THESE CAVITIES REQUIRE DELPHI-PACKARD GT150 TERMINALS/SEALS.

ALL OTHERS REQUIRE DELPHI-PACKARD GT280 TERMINALS/SEALS.

7 SHIM CONNECTOR HOUSING AT C1,C3,C4 & C5 WITH 16.84mm x 0.43mm

EXTERNAL EXTRUSION LOCATED ON CENTER.

8 WHEN BATTERY FEED IS PROVIDED TO VBAT4, MARKER LAMP OUTPUTS CAN BE USED
AT HIGH OUTPUT RATING. VBAT4 IS DIRECTLY CONNECTED TO VBAT2.

9 THIS PIN WAS J1708

THE INFORMATION CONTAINED HEREIN IS PROPRIETARY DATA, AND IS NOT FOR DISSEMINATION OR ITEM/DRAWING NUMBER REVISION LETTER PAGE
DISCLOSURE, IN WHOLE OR IN PART, FOR ANY PURPOSE OTHER THAN THAT FOR WHICH IT
Daimler Trucks
ISSUBMITTED, EXCEPT AS AUTHORIZED IN WRITING BY DAIMLER TRUCKS NORTH AMERICA LLC (DTNA) North America 06-75158 A 2 of 9
 7

TAIL HARNESS
MATING CONNECTOR 23-13144-005

TRAILER MODULE HARNESS

MATING CONNECTOR 23-13144-800

FORWARD CHASSIS HARNESS

MATING CONNECTOR 23-13144-006

7
AMU HARNESS
MATING CONNECTOR 23-13144-004
1
7
FORWARD CHASSIS HARNESS
MATING CONNECTOR 23-13144-007 ISO VIEW
FOR REFERENCE ONLY

THE INFORMATION CONTAINED HEREIN IS PROPRIETARY DATA, AND IS NOT FOR DISSEMINATION OR ITEM/DRAWING NUMBER REVISION LETTER PAGE
DISCLOSURE, IN WHOLE OR IN PART, FOR ANY PURPOSE OTHER THAN THAT FOR WHICH IT
Daimler Trucks
ISSUBMITTED, EXCEPT AS AUTHORIZED IN WRITING BY DAIMLER TRUCKS NORTH AMERICA LLC (DTNA) North America 06-75158 A 3 of 9
 TOP VIEW

SIDE VIEW

FRONT VIEW

THE INFORMATION CONTAINED HEREIN IS PROPRIETARY DATA, AND IS NOT FOR DISSEMINATION OR ITEM/DRAWING NUMBER REVISION LETTER PAGE
DISCLOSURE, IN WHOLE OR IN PART, FOR ANY PURPOSE OTHER THAN THAT FOR WHICH IT
Daimler Trucks
ISSUBMITTED, EXCEPT AS AUTHORIZED IN WRITING BY DAIMLER TRUCKS NORTH AMERICA LLC (DTNA) North America 06-75158 A 4 of 9
 TAIL HARNESS

Current (A)
Nominal Vehicle Load
CONNECTOR PIN SIGNAL NAME TYPE POWER FEED @ 25 °C; 12VDC
C1-A /4\ Left Backup Lamp DO VBAT 2 & 4 2.5

C1-B Service Brake 2 DI (Active High); - -

WK UP

C1-C /6\ - - - -

C1-D /4\ Left Tail Lamp Pass Through - 0.7

C1-E /4\ Right Tail Lamp Pass Through - 0.7

C1-F /4\ License Plate Lamp Pass Through - 0.7

C1-G /4\ Turn Left Rear DO VBAT 2 & 4 2.5

C1-H /4\ Backup Alarm DO VBAT 2 & 4 0.5

C1-J /4\ Right Backup Lamp DO VBAT 2 & 4 2.5

C1-K /6\ - - - -

C1-L Right Stop Lamp DO VBAT 1 2.5

C1-M /6\ - - - -

C1-N Left Stop Lamp DO VBAT 1 2.5

C1-P /4\ Turn Right Rear DO VBAT 1 2.5

THE INFORMATION CONTAINED HEREIN IS PROPRIETARY DATA, AND IS NOT FOR DISSEMINATION OR ITEM/DRAWING NUMBER REVISION LETTER PAGE
DISCLOSURE, IN WHOLE OR IN PART, FOR ANY PURPOSE OTHER THAN THAT FOR WHICH IT
Daimler Trucks
ISSUBMITTED, EXCEPT AS AUTHORIZED IN WRITING BY DAIMLER TRUCKS NORTH AMERICA LLC (DTNA) North America 06-75158 A 5 of 9
 TRAILER HARNESS

Current (A)
Nominal Vehicle Load
CONNECTOR PIN SIGNAL NAME TYPE POWER FEED @ 25 °C; 12VDC
C2-A Trailer Power Relay DO LSD 0.2

C2-B /6\ - - - -

C2-C GND Power Ground - 0.2

C2-D Trailer Stoplamp Relay Pass Through (Active - 0.2

Low);
WK UP

C2-E /4\ Trailer Turn Right DO VBAT 1 0.2

C2-F /4\ Trailer Marker Relay DO VBAT 2 & 4 0.2

C2-G /4\ Trailer Tail Relay Pass Through - 0.2

C2-H /4\ Trailer Turn Left DO VBAT 2 & 4 0.2

THE INFORMATION CONTAINED HEREIN IS PROPRIETARY DATA, AND IS NOT FOR DISSEMINATION OR ITEM/DRAWING NUMBER REVISION LETTER PAGE
DISCLOSURE, IN WHOLE OR IN PART, FOR ANY PURPOSE OTHER THAN THAT FOR WHICH IT
Daimler Trucks
ISSUBMITTED, EXCEPT AS AUTHORIZED IN WRITING BY DAIMLER TRUCKS NORTH AMERICA LLC (DTNA) North America 06-75158 A 6 of 9
 FORWARD CHASSIS HARNESS
Current (A)
Nominal Vehicle Load
CONNECTOR PIN SIGNAL NAME TYPE POWER FEED @ 25 °C; 12VDC
C3-A Fuel Water Separator Heater HSD DO VBAT 3 20

C3-B /6\ - - - -
C3-C /4\ Fog/Road Lamps DO VBAT 1 3.35
C3-D /4\ Fog/Road Lamps DO VBAT 1 3.35

C3-E Low Air Pressure / Spare CA/S #1 DI (Active Low) / AI - -

C3-F Park Brake DI (Active Low) - -

C3-G Service Brakes DI (Active Low); - -
WK UP

C3-H GND Power Ground - -

C3-J VBAT2 Power - 30
C3-K Right DRL DO VBAT 1 4
C3-L Right Low Beam DO VBAT 1 4.8
C3-M Ignition DI (Active High); WK - -
UP

C3-N /4\ Turn Left Front/Side DO VBAT 2 & 4 2.85

C3-P /4\ Tail/License Plate Lamps Pass Through - 2.3
C3-R /4\ Turn Right Front/Side DO VBAT 1 2.85
C3-S /8\ /9\ VBAT4 POWER - 30

THE INFORMATION CONTAINED HEREIN IS PROPRIETARY DATA, AND IS NOT FOR DISSEMINATION OR ITEM/DRAWING NUMBER REVISION LETTER PAGE
DISCLOSURE, IN WHOLE OR IN PART, FOR ANY PURPOSE OTHER THAN THAT FOR WHICH IT
Daimler Trucks
ISSUBMITTED, EXCEPT AS AUTHORIZED IN WRITING BY DAIMLER TRUCKS NORTH AMERICA LLC (DTNA) North America 06-75158 A 7 of 9
 FORWARD CHASSIS HARNESS

Current (A)
Nominal Vehicle Load
CONNECTOR PIN SIGNAL NAME TYPE POWER FEED @ 25 °C; 12VDC
C4-A Wake-Up DI/O; - -
WK UP

C4-B Address Strapping A AI - -

C4-C /4\ Left Park Lamp DO VBAT 2 & 4 0.7

C4-D /4\ Left Marker Lamp DO VBAT 2 & 4 0.7

C4-E Address Strapping C AI - -

C4-F Left DRL DO VBAT 2 & 4 4

C4-G CAN_H COM - -

C4-H GND(Address Strapping D) Signal GND - -

C4-J VBAT3 Power - 30

C4-K Right High Beam DO VBAT 2 & 4 5.6

C4-L /4\ Right Park Lamp DO VBAT 2 & 4 0.7

C4-M /4\ Right Marker Lamp DO VBAT 2 & 4 0.7

C4-N Address Strapping B AI - -

C4-P VBAT1 Power - 30

C4-R CAN_L COM - -

C4-S GND Power Ground - -

THE INFORMATION CONTAINED HEREIN IS PROPRIETARY DATA, AND IS NOT FOR DISSEMINATION OR ITEM/DRAWING NUMBER REVISION LETTER PAGE
DISCLOSURE, IN WHOLE OR IN PART, FOR ANY PURPOSE OTHER THAN THAT FOR WHICH IT
Daimler Trucks
ISSUBMITTED, EXCEPT AS AUTHORIZED IN WRITING BY DAIMLER TRUCKS NORTH AMERICA LLC (DTNA) North America 06-75158 A 8 of 9
 AMU HARNESS

Current (A)
Nominal Vehicle Load
CONNECTOR PIN SIGNAL NAME TYPE POWER FEED @ 25 °C; 12VDC
C5-A AMU AIN0 DI (Active Low) / AI - -

C5-B AMU AIN1 DI (Active Low) / AI - -

C5-C GND Signal Ground - -

C5-D /6\ - - - -

C5-E /6\ - - - -

C5-F AMU AIN2 DI (Active Low) / AI - -

C5-G AMU AIN3 DI (Active Low) / AI - -

C5-H AMU Solenoid0 DO VBAT 3 1.5A

C5-J AMU Solenoid1 DO VBAT 3 1.5A

C5-K /6\ - - - -

C5-L AMU Solenoid2 DO VBAT 3 1.5A

C5-M AMU Solenoid3 DO VBAT 3 1.5A

THE INFORMATION CONTAINED HEREIN IS PROPRIETARY DATA, AND IS NOT FOR DISSEMINATION OR ITEM/DRAWING NUMBER REVISION LETTER PAGE
DISCLOSURE, IN WHOLE OR IN PART, FOR ANY PURPOSE OTHER THAN THAT FOR WHICH IT
Daimler Trucks
ISSUBMITTED, EXCEPT AS AUTHORIZED IN WRITING BY DAIMLER TRUCKS NORTH AMERICA LLC (DTNA) North America 06-75158 A 9 of 9