MFMA 2004 Guidelines
MFMA 2004 Guidelines
MFMA 2004 Guidelines
MFMA-103
www.metalframingmfg.org
Metal Framing Manufacturers Association 2004
All Rights Reserved
$5.00
FOREWARD
This publication provides general guidelines for the use of continuous slot-channel metal framing and
strut-type channel raceway, supplementing instructions of individual metal framing manufacturers. While
it is not intended to be an all-inclusive document, it does highlight a number of important factors relative
to the use of metal framing.
The safety of the total system involves the system designer, installer, and user. The manufacturer has
limited or no control over factors such as environmental conditions, total system design, product selection
and application, installation practices, and system maintenance. Consequently, the Metal Framing
Manufacturers Association (MFMA) disclaims all warranties, express and implied, associated with this
Guideline publication. The Guideline has been developed with a view towards promoting safety to
persons and property when the metal framing system is properly selected and when installed as an
electrical raceway, it shall be installed according to Article 384 of the National Electrical Code.
For additional information with regard to metal framing, see MFMA’s Metal Framing Standards
Publication, latest edition, as well as individual manufacturers’ catalogs.
This Guideline has been developed in the public interest and is intended to promote a better
understanding between the manufacturer and the user. It is intended to assist the user in selecting and
obtaining the proper product for a particular need. However, as a matter of policy, MFMA neither renders
decisions or opinions on questions relating to the selection and use of specific metal framing systems in
individual situations, nor renders decisions or opinions on questions relating to compliance by specific
metal framing manufacturers or their products with MFMA standards or guidelines. Any specific
technical questions should be directed to MFMA members listed in Appendix A.
This Guideline discusses design and technology commonly seen in the metal framing industry today. It is
neither intended as, nor should it be construed as, a statement against or an impediment to new metal
framing design and technology as the industry continues to grow.
This Guideline will be reviewed and updated periodically. MFMA will continue to welcome written
comments from interested parties at any time. All such comments should be addressed to :
Page
SECTION 1 GUIDELINES FOR DESIGN 1
SECTION 3 BRACING 3
SECTION 6 TEMPERATURE 4
Finishes 4
Materials 4
Electrical 4
Installed Loads (Pipe) 4
Dissimilar Materials 4
SECTION 10 SUPPORT 8
Channel Support from Beams 8
Trapeze Support 8
Channel Joiners 8
Wall Brackets (Cantilevered Load) 8
Nonmetallic Pipe or Conduit Support 8
There are many factors to be considered in the general design of metal framing systems. Some basic
considerations that should be addressed during the design of any metal framing system are:
1.2 Applicable building codes, standards, and specifications that may preempt manufacturer’s
published design data.
1.3 Applicable electrical specifications such as the National Electrical Code, Underwriters
Laboratories, Standard UL5B, MFMA, etc.
1.4 The environment (temperature, moisture, corrosive atmosphere, etc.) in which the system will be
placed.
1.7 Selection and proper use of channel, fittings, accessories, and fasteners.
1.8 Deflection.
1.11 Selection of materials and finishes to prevent galvanic reaction between mating components.
Note for clause 1.12: One company does not support the change “shall be permitted” for subclause 1.12
for the reason: In standard language, the word “shall” denotes a mandatory requirement, which cannot
be in a section that starts with “…Some basic considerations should be addressed…” “Should” is the
term for voluntary action or consideration. Since these are guidelines, we better remain with the word
“used.”
1.12 Strut-type channel raceway used as an equipment grounding conductor, in accordance with NEC
(National Electrical Code) Article 250.118(14).
-1-
SECTION 2
TYPES OF BEAMS AND LOADING
-2-
SECTION 3
BRACING
3.1 Metal framing systems should have adequate lateral, seismic, and sway bracing to withstand all
static and dynamic loading conditions to which the system may be subjected.
3.2 Some factors that affect bracing are weight of system, length of bracing, section properties, type
of material, usage, connections, load, size of systems, etc.
3.3 Bracing should be spaced based on the manufacturer’s recommendations for the service
condition.
3.4 Consideration must be given to whether bracing elements will be in tension, compression,
torsion, or combination(s) thereof.
SECTION 4
LOADING DURING INSTALLATION
In the design of any system, consideration should be given to the loads that may be imposed on the
system during installation as well as those when the system is complete. It is not unusual for temporary
loading during installation to be substantially greater and of a different nature than that when the system
is complete. These may vary with the loading and installation. While not limited to these, the following
are examples of some of these temporary conditions:
4.4 Loading due to environmental factors such as wind, snow, temperature change, etc., that may not
be significant in the finished installation.
4.6 Accidental impact such as bumping with a forklift or the dropping of equipment.
SECTION 5
SAFETY FACTORS
5.1 When tests are used to determine the maximum design load, the manufacturer’s published data
will often include a safety factor. The safety factor usually is defined by the manufacturer as the
ratio of the ultimate load to the maximum design load.
5.3 The loads of 5.1 and 5.2 have been developed through either calculations or testing and have been
determined for the safety of both the user and the manufacturer.
-3-
SECTION 6
TEMPERATURE
6.1 FINISHES
Channel finish usually will limit the maximum temperature to which a metal framing system
should be exposed. Elevated temperatures may cause deterioration. Consult manufacturer for
suitability of specific finishes.
6.2 MATERIALS
When channel is used at temperatures above 300F (149C), the manufacturer should be
consulted for the corrected modulus of elasticity, allowable stress, and guidance in support and
joining to allow for expansion.
6.3 ELECTRICAL
Strut-type channel raceway shall be installed in accordance with the National Electrical Code,
Article 384, as a minimum requirement.
Piping should be properly clamped, guided, and anchored to allow for thermal expansion and
elimination of vibration that will cause pipe to move in an undesirable manner.
-4-
SECTION 7
CHANNEL NUTS
The channel nut provides the gripping power needed to complete a rigid metal framing connection.
7.1 COMPONENTS
The channel nut often consists of two components; the nut and an optional retaining device.
Since the channels and nuts come in many variations, it is important to select the proper
combination.
7.1.1 The typical channel nut is designed to be inserted through the channel slot and then
turned 90 into place. Care must be taken to ensure proper alignment of the nut within
the channel. The most common nut sizes are for 1/4”, 3/8” and 1/2” bolts; however, other
sizes are available.
7.1.2 The purpose of the retaining device is to hold the channel nut in proper position during
assembly. Once the bolt has been properly installed, the retaining device serves no
further function.
7.3 ASSEMBLY
To achieve the manufacturer’s rated design slip and pullout loads, a general fitting must be
attached to the channel surface by a bolt and channel nut using the proper bolt (to the
manufacturer’s standard). All connections should be assembled using clean, dry components.
The use of lubricants or torque sprays can cause excessively high bolt tension for a given torque
resulting in damage to bolt, nut, and/or channel. The effects of over-torquing (excessive bolt
tension) could include twisted bolt heads, bent or cracked nuts, crushed channel lips, or deformed
fitting(s).
7.4 PRECAUTIONS
7.4.1 When a channel nut is placed near the end of a member, it has a lower ultimate pullout
load. A good rule of thumb cuts the design load in half within the last one inch of the
member.
7.4.2 Over-tightening of threaded rod against channel back will cause serious damage to
channel lips, reducing load-carrying capacity and possibly causing premature failure.
7.4.3 When bolting through a pierced channel, over-torquing may crush the channel.
It must be emphasized that proper seating and torquing is essential to the performance of the channel nuts.
A fastener that is not tightened to the manufacturer’s recommended torque will not consistently meet the
manufacturer’s minimum published design loads. Design slip and pullout loads for channel nuts are
determined by the manufacturer and must not be exceeded (see test methods in the applicable section of
MFMA’s Metal Framing Standards Publication, latest edition.)
-5-
SECTION 8
CONCRETE INSERTS
8.1 APPLICATION
Concrete inserts provide a pre-set support system in cast-in-place and precast concrete ceilings,
walls, and floors. They provide flexibility of fasteners’ size and location to attach equipment and
accessories and may be integrated into framing systems for the support of piping, conduit, or
cable tray. Concrete inserts are commonly used to support curtain and window walls in building
structures.
8.2 TYPES
There are two types of inserts common to the metal framing industry, as well as special inserts
developed by individual manufacturers for particular applications. The two standard types are
“Continuous Slot Concrete Inserts” and “Spot Concrete Inserts.”
There are two basic types of end caps. One fits flush with the end of the insert and has no
protrusions or extensions. Its sole function is to inhibit concrete seepage. The second type of end
cap is used as an anchor in the concrete. This one-piece cap is formed with a bent tab that
provides additional anchorage at the end of the insert.
The inside of the concrete insert must be kept clear for the proper installation of the channel nut.
End caps and closures are available for use with continuous concrete inserts to inhibit seepage.
Closure or fillers come in a variety of forms and materials such as metal, plastic, polystyrene
foam, cardboard, tape, etc.
-6-
8.5 INSTALLATION
The user should confer with the engineering firm responsible for the design of the project to
assure that the use of a particular insert is appropriate. The concrete insert manufacturer has no
responsibility for the concrete design. Manufacturers’ load ratings usually are based upon a
concrete of 2,500 to 3,000 PSI design strength. Load ratings at other concrete design strengths
may be available and the manufacturer should be consulted. Inserts must be surrounded by
sufficient concrete to conform to design shear stress. The insert must be securely attached to the
form before the concrete is poured. Continuous contact of concrete insert with form must be
maintained to assure a flush, mounting surface. They must be used properly in accordance with
the manufacturers’ recommendation.
Concrete inserts provide a fastening system to concrete that is unique, but they must be installed
and used properly.
8.7.1 Proper sealing and attachment to the form work will keep the insert free from concrete
and provide a flush finish surface.
8.7.2 If insert is recessed, provide shims between insert and finish surface.
8.7.3 Any temporary construction loading should not exceed design loading.
8.7.4 Single-point loading of continuous concrete inserts should not exceed manufacturer’s
per-foot load rating.
8.7.6 Over-tightening of threaded rod against insert back will cause serious damage to insert
lips, reducing the load-carrying capacity and possibly causing premature failure.
8.7.7 Anchors or anchoring devices on concrete inserts should never be removed, bent,
deformed, or otherwise altered. To do so can result in a serious hidden reduction in the
insert’s load-carrying capacity.
8.7.8 Concrete inserts should not be used for rigging, due to the potential for overload and
damage.
-7-
SECTION 9
SWIVEL AND SWING FITTINGS
9.1 Swivel and swing fittings are used primarily for alignment or where movement can be expected
after installation and a rigid connection would not be desirable. Swivel fittings are used where
movement is within a single plane. Consideration should be given to resultant loads and care
should be taken to see that manufacturer’s recommended maximum angular movement is not
exceeded in any direction.
9.2 While not limited to the following, these are examples of potential applications:
SECTION 10
SUPPORT
When channel is supported directly from beams, it should completely overlap the beam flange.
Clamps always should be used in pairs and should be located as close to the beam flange as
possible. In addition to load, consideration should be given to the channel depth as well as the
beam-flange width and thickness in selecting channel-beam clamps.
It is suggested that the center-to-center distance between two pipes or conduits be sufficient to
allow two couplings to be adjacent to each other as well as room for the fastening or clamping
device.
Best practice is to locate joiners or couplings at points of minimum moment. This will usually be
within one-third (1/3) of the span from supports.
Wall brackets usually are rated in inch-pounds of moment. It is important not to exceed this
rating. To determine inch-pounds, calculate the load and determine the location of its center. The
product of the total load, times the inches’ distance from the wall to the center of the load, is the
loading moment in inch-pounds. Consideration also should be given to the strength of fasteners
or anchors being used.
-8-
SECTION 11
ARCHITECTURAL AND MAINTENANCE PAINTING
The following are general steps that should be followed when an architectural or maintenance painting
program is required. In all cases, the specific instructions of the channel manufacturer and paint
manufacturer should be followed.
11.1 Determine type of surface to be painted (most manufacturers offer more than one finish or
material). Some finishes and/or materials may not require architectural or maintenance painting.
11.2 The following is a list of more common surface finishes of channel and fittings:
11.3 Some surfaces are not readily paintable. Consult manufacturer for specific painting
recommendations.
11.4 The application of architectural or maintenance coatings changes the dimensions of the channel
and may affect the subsequent assembly of fittings and accessories.
11.5 Select finish to be applied considering manufacturer’s recommendations and required resistance
to corrosion, temperature, and environmental conditions.
11.6 Thoroughly clean surfaces per manufacturer’s instructions. This is particularly important with
unfinished carbon steel.
11.7 Prime coat surface as recommended by manufacturer. Some surfaces may not require prime
coating.
-9-
APPENDIX A
METAL FRAMING MANUFACTURERS ASSOCIATION
MEMBER COMPANIES
(Revised 07/16)
Cooper B-Line
509 West Monroe Street
Highland, IL 62249
Flex-Strut, Inc.
2900 Commonwealth Ave., NE
Warren, OH 44483
G-STRUT
4100 13th St., SW
Canton, OH 44710
Haydon Corporation
415 Hamburg Turnpike
Wayne, NJ 07470
Unistrut
35660 Clinton Drive
Wayne, MI 48184-2091
Wesanco, Inc.
14870 Desman Road
La Mirada, CA 90638
- 10 -