Yaris PDF
Yaris PDF
NOTICE
Always follow the directions given in the above repair manuals when handling
supplemental restraint system components (such as removal, installation,
inspection, etc.) in order to prevent accidents and supplemental restraint
system malfunction.
©2009
All rights reserved. This book may not be
reproduced or copied, in whole or in part, without
the written permission of Toyota Motor
Corporation.
YARIS
ELECTRICAL WIRING DIAGRAM
Section Code Page
INTRODUCTION . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . A . . . . 2
TROUBLESHOOTING . . . . . . . . . . . . . . . . . . . . . . . . . C . . . . 12
ABBREVIATIONS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . D . . . . 17
RELAY LOCATIONS . . . . . . . . . . . . . . . . . . . . . . . . . . . F . . . . 20
SYSTEM CIRCUITS . . . . . . . . . . . . . . . . . . . . . . . . . . . . H . . . . 82
YARIS (EM02C4EL)
A INTRODUCTION
This manual consists of the following 13 sections:
TROUBLE–
C Describes the basic inspection procedures for electrical circuits.
SHOOTING
GLOSSARY OF
E TERMS AND Defines the symbols and functions of major parts.
SYMBOLS
Shows position of the Electronic Control Unit, Relays, Relay Block, etc.
F RELAY LOCATIONS
This section is closely related to the system circuit.
ELECTRICAL Describes position of Parts Connectors, Splice points, Ground points, etc.
G
WIRING ROUTING This section is closely related to the system circuit.
Electrical circuits of each system are shown from the power supply through ground
H points. Wiring connections and their positions are shown and classified by code
according to the connection method. (Refer to the section, ”How to use this manual”).
SYSTEM CIRCUITS
The ”System Outline” and ”Service Hints” useful for troubleshooting are also contained
in this section.
(Only wiring information for complete circuits is included.)
I GROUND POINT Shows ground positions of all parts described in this manual.
POWER SOURCE
J Describes power distribution from the power supply to various electrical loads.
(Current Flow Chart)
Describes the form of the connectors for the parts appeared in this book.
K CONNECTOR LIST
This section is closely related to the system circuit.
PART NUMBER OF
L Indicates the part number of the connectors used in this manual.
CONNECTORS
OVERALL
Provides circuit diagrams showing the circuit connections.
M ELECTRICAL
(Only wiring information for complete circuits is included.)
WIRING DIAGRAM
YARIS (EM02C4EL)
HOW TO USE THIS MANUAL B
The actual wiring of each system circuit is shown from the point where the power
source is received from the battery as far as each ground point. (All circuit
diagrams are shown with the switches in the OFF position.)
When troubleshooting any problem, first understand the operation of the circuit
where the problem was detected (see System Circuit section), the power source
supplying power to that circuit (see Power Source section), and the ground points
(see Ground Point section).
Example:
*The information in this manual is Front right door When inspecting or repairing,
refer to the Repair Manual.
about the wire harnesses.
Information about component and
assembly parts is for reference,
but in some cases this reference
information might not be included or
might differ from the actual vehicle.
When inspecting or repairing a vehicle,
refer to the relevant Repair Manual.
Wire harness
Component parts
Assembly parts
YARIS (EM02C4EL)
B HOW TO USE THIS MANUAL
* The system shown here is an EXAMPLE ONLY. It is different to the actual
circuit shown in the SYSTEM CIRCUITS SECTION.
[A]
Stop Light
[M]
(BAT) (IG)
15A 7.5A
STOP GAUGE
[B] 1 3 IB 4 IB
R–L
W–R
(S/D)
7 3C
L
[C] [G]
H6
Stop Lamp SW
14 CH1 15 3C
R–L
(W/G)
(S/D)
R
L
G–W
Combination Meter
4
Skid Control ECU
15 CH1 [E]
Lights
with Actuator
Rear
G–W
[D]
H7
13
(S/D)
L
G–W
[F] [O]
Y–G
H4
7 8 Light Failure Sensor 4
2 1 11
[I]
G–R
1
G–R
HJ1 [N]
[H]
W–B
G–B
Rear Combination Lamp (RH)
(Shielded)
G–R
4 3
2
H17
[J]
Stop
Stop
Center Stop
Lamp
1
H9
J7
3 6
W–B
W–B
W–B
1
W–B
HJ1
W–B
H1 [K] H2
50 [L]
YARIS (EM02C4EL)
B
[A] : System Title [I] : Indicates the wiring color.
[B] : Indicates a Relay Block. No shading is used and Wire colors are indicated by an alphabetical code.
only the Relay Block No. is shown to distinguish it B = Black W = White BR = Brown
from the J/B
L = Blue V = Violet SB = Sky Blue
Example: Indicates Relay Block No.1
R = Red G = Green LG = Light Green
[C] : ( ) is used to indicate different wiring and P = Pink Y = Yellow GR = Gray
connector, etc. when the vehicle model, engine
type, or specification is different. O = Orange BE = Beige
The first letter indicates the basic wire color and the
[D] : Indicates related system. second letter indicates the color of the stripe.
[E] : Indicates the code for the (male and female)
connectors which are used to join two wire Example: L–Y
harnesses. The connector code consists of two
alphabetical and one numerical characters.
L Y
(Blue) (Yellow)
The first character of the connector code indicates Example: Numbered in order Numbered in order
the alphabetical code allocated to the wire harness from upper left to from upper right to
which has the female connector, and the second lower right lower left
shows that of the wire harness which has the male
connector.
The third character indicates a serial number used
to distinguish between the wire harness
combinations in cases when more than one of the Female Male
same combination of wire harnesses exist
(e.g. CH1 and CH2). [K] : Indicates the ground point. The code consists of the
two characters: A letter and number.
Symbol ( ) indicates the male terminal connector. The first character of the code indicates the
Numbers outside connector codes indicate the pin alphabetical code allocated to the wire harness.
numbers of both male and female connectors. The second character indicates a serial number
used to distinguish between the ground points in
[F] : Represents a part (all parts are shown in sky blue). cases when more than one ground point exist on the
The code is the same as the code used in parts same wire harness.
position.
[L] : Page No.
[G] : Junction Block (The number in the circle is the J/B
No. and the connector code is shown beside it). [M] : Indicates the ignition key position(s) when the
Junction Blocks are shaded to clearly separate power is supplied to the fuse(s).
them from other parts. [N] : Indicates a wiring Splice Point.
Example:
Example:
3C indicates that
it is inside
Junction Block
No.3
[O] : Wire Harness Code
Each wire harness is represented by a code.
Wire harness codes are used in the parts codes,
[H] : Indicates a shielded cable. connector joining wire harness and wire harness
codes, and ground point codes. For example,
H7 (combination meter), CH1 (male, connector
joining wire harness and wire harness), and H2
(ground point) indicate that they are the parts
belonging to the same wire harness "H".
YARIS (EM02C4EL)
B HOW TO USE THIS MANUAL
[P] : Parts Location
Code See Page Code See Page Code See Page
H4 36 H7 36 H17 38
H6 36 H9 38 J7 38
Code See Page Junction Block and Wire Harness (Connector Location)
3C 22 Instrument Panel Wire and J/B No.3 (Instrument Panel Brace LH)
IB 20 Instrument Panel Wire and Instrument Panel J/B (Lower Finish Panel)
YARIS (EM02C4EL)
B
[P] : Indicates reference pages showing the parts locations in the system circuit on the vehicle.
Example : Code ”H4” (Light Failure Sensor) is on page 36 of the manual.
* The first character of the code indicates the alphabetical code allocated to the wire harness, and the
second character indicates the serial number of the parts connected to the wire harness.
Example : H 4
Serial number for the connected parts
Code for the wire harness
[Q] : Indicates the reference page showing the position on the vehicle of Relay Block Connectors in the system circuit.
Example : Connector ”1” is described on page 18 of this manual and is installed on the left side of the instrument
panel.
[R] : Indicates the reference page showing the position on the vehicle of J/B and Wire Harness in the system circuit.
Example : Connector ”3C” connects the Instrument Panel Wire and J/B No.3. It is described on page 22 of this
manual, and is installed on the instrument panel left side.
[S] : Indicates the reference page describing the wiring harness and wiring harness connector (the female wiring
harness is shown first, followed by the male wiring harness).
Example : Connector ”CH1” connects the Engine Room Main Wire (female) and Instrument Panel Wire (male).
It is described on page 42 of this manual, and is installed on the left side kick panel.
[T] : Indicates the reference page showing the position of the ground points on the vehicle.
Example : Ground point ”H2” is described on page 50 of this manual and is installed on the back panel center.
YARIS (EM02C4EL)
B HOW TO USE THIS MANUAL
The ground points circuit diagram shows the connections from all major parts to the respective ground points. When
troubleshooting a faulty ground point, checking the system circuits which use a common ground may help you identify
the problem ground quickly. The relationship between ground points ( A1 , A2 and D4 shown below) can also be
checked this way.
I GROUND POINT
D43
Junction
H23 Connector
12 9
DLC3 BR BR BR 10 6 (Shielded)
(SG) HB4 DB1
D63
5 BR Throttle
(L)
(Shielded)
(Shielded)
Position SW
D60
A20 4 3 BR Injection
W–B 8 (E1) Pump Assembly
Headlamp Leveling
Motor (LH) (LH E)
L5 2 11 BR
W–B 3 W–B 7 (E1)
Power Window
Master SW (E) LA1
1 D2
BR Engine ECU
(E01)
Connector
A22
BR
W–B 4 Junction
Cooling Fan
Motor No.3 (E) BR
A25
(E02)
3
W–B
D4 (5L–E)
A8
Headlamp Leveling W–B
Motor (RH) (RH E)
A5 C2
W–B W–B
W–B
A23 5 C4
Turn Signal Lamp W–B W–B W–B W–B Fog Lamp
(Front LH) (E) CA1 (E) (Front RH)
A11 A10
W–B W–B
W–B
I9 12 7 A1
Headlamp W–B W–B W–B W–B Turn Signal Lamp
Leveling SW (E) IH2 HA1 (E) (Front RH)
W–B
A6
Clearance Lamp W–B K5
(Front RH) (E) 3
W–B W–B Power Window
KA1 (E) Master SW
W–B
A21
Clearance Lamp W–B W–B
(Front LH) (E)
20 W – B (Shielded)
A1
19 W – B (Shielded)
W–B
(GND2) 18 W – B (Shielded)
A24
Option Connector
(Vacuum)
Connector
W–B
Junction
(GND1) 17 W – B (Shielded)
W–B
B36
21 16
W–B W–B
(GND) AB1
W–B
B19
Skid Control ECU
with Actuator 12 6
W–B W–B W–B
(GND) AB1 AB1
W–B
W–B
W–B
A2
* The system shown here is an EXAMPLE ONLY. It is different to the actual circuit shown in the SYSTEM CIRCUITS SECTION.
YARIS (EM02C4EL)
B
The ”Current Flow Chart” section, describes which parts each power source (fuses, fusible links, and circuit breakers)
transmits current to. In the Power Source circuit diagram, the conditions when battery power is supplied to each system
are explained. Since all System Circuit diagrams start from the power source, the power source system must be fully
understood.
10A ECU–B
Short Pin 2 2
7.5A DOME
15A EFI
Power Source
1.25B
B 1 FL MAIN
W
BA1
Battery
50A MAIN 7.5A DOME
B W 7 W W 1 2 R
1 2
2 2 AH1 1 1
7.5A AM1
B W–R 6
1 2
2 2 AH1
W
W–R
15A HAZ–RADIO
1 2 W
2
8 4
AM1
AM2
H8
Ignition SW
ACC
ST1
ST2
IG1
IG2
2
20A DEFOG
B–Y 1 2 W–R
1 1
* The system shown here is an EXAMPLE ONLY. It is different to the actual circuit shown in the SYSTEM CIRCUITS SECTION.
YARIS (EM02C4EL)
B HOW TO USE THIS MANUAL
K CONNECTOR LIST
A1 [A] A2 A3 [C]
Black Gray
1 2 3 4 1 2 3 4 5 6 7
1 2 3 4
5 6 7 8
[B] [D]
B1 B2
Black Gray
1 2
3 4 5 6
1 2 3 4 5
6 7 8 9 10111213
K CONNECTOR LIST
BA1 Black
[E] BD2 Gray [F]
1 2 3 4 4 3 2 1
1 2 3 4 5 5 4 3 2 1 5 6 7 8 9 10 11 11 10 9 8 7 6 5
6 7 8 9 10 11 12 13 13 12 11 10 9 8 7 6
[A] : Indicates connector to be connected to a part. (The numeral indicates the pin No.)
Short Terminal
[E] : Indicates the connector shapes which are used to join wire harnesses.
On Left : Female connector shapes
On Right : Male connector shapes
Numbers indicate pin numbers.
[F] : Indicates connector colors. (Connectors with not indicated colors are white)
10
YARIS (EM02C4EL)
B
A1 Turn Signal Lamp (Front RH) 90980–11019 B22 Door Courtesy SW (Front LH) 90980–12470
A2 Inlet Air Temp. Sensor 90980–11163 B23 Front Seat Outer Belt (LH) 90980–12253
A4 A/C Pressure Sensor 90980–10845 B25 Front Seat Outer Belt (RH) 90980–12253
A6 Clearance Lamp (Front RH) 90980–11156 B27 Cooling Fan ECU No.1
90980–10841
[A]
A7 [B](RH)
Headlamp [C]
90980–11314 B28 Cooling Fan ECU No.2
A8 Headlamp Leveling Motor (RH) 90980–11016 B29 Water Temp. Sensor (Radiator) 90980–10735
A10 Brake Fluid Level Warning SW 90980–11207 B32 Door Control Relay (LH) 90980–10789
A11 Windshield Washer Motor 90980–11599 B33 Step Lamp (LH) 90980–10121
Not all of the above part numbers of the connector are established for the supply.
11
YARIS (EM02C4EL)
C TROUBLESHOOTING
To Ignition SW VOLTAGE CHECK
IG Terminal
(a) Establish conditions in which voltage is present at the check
point.
Example:
Fuse [A] – Ignition SW on
[B] – Ignition SW and SW 1 on
[A] [C] – Ignition SW, SW 1 and Relay on (SW 2 off)
(b) Using a voltmeter, connect the negative lead to a good ground
SW 1 Voltmeter point or negative battery terminal, and the positive lead to the
connector or component terminal.
[B] This check can be done with a test light instead of a voltmeter.
Relay
[C]
SW 2 Solenoid
SW
If the circuit has diodes, reverse the two leads and check
again.
When contacting the negative lead to the diode positive side
Ohmmeter and the positive lead to the negative side, there should be
continuity.
When contacting the two leads in reverse, there should be no
continuity.
Diode
Digital Type Analog Type (c) Use a volt/ohmmeter with high impedance (10 k /V
minimum) for troubleshooting of the electrical circuit.
12
YARIS (EM02C4EL)
C
To Ignition SW FINDING A SHORT CIRCUIT
IG Terminal
(a) Remove the blown fuse and disconnect all loads of the fuse.
(b) Connect a test light in place of the fuse.
(c) Establish conditions in which the test light comes on.
Test Light Fuse Case Example:
[A] – Ignition SW on
Short [A]
[B] – Ignition SW and SW 1 on
[C] – Ignition SW, SW 1 and Relay on (Connect the
Relay) and SW 2 off (or Disconnect SW 2)
SW 1 (d) Disconnect and reconnect the connectors while watching the
test light.
Short [B] The short lies between the connector where the test light
stays lit and the connector where the light goes out.
Disconnect
Disconnect (e) Find the exact location of the short by lightly shaking the
problem wire along the body.
Light Relay
CAUTION:
(a) Do not open the cover or the case of the ECU unless
Short [C] absolutely necessary. (If the IC terminals are touched,
the IC may be destroyed by static electricity.)
(b) When replacing the internal mechanism (ECU part) of
Disconnect
the digital meter, be careful that no part of your body or
clothing comes in contact with the terminals of leads
SW 2 Solenoid from the IC, etc. of the replacement part (spare part).
Pull Up Pull Up
13
YARIS (EM02C4EL)
C TROUBLESHOOTING
Reference: HOW TO REPLACE TERMINAL
(with terminal retainer or secondary locking device)
10 1. PREPARE THE SPECIAL TOOL
3 1
HINT : To remove the terminal from the connector, please
construct and use the special tool or like object shown on
the left.
2. DISCONNECT CONNECTOR
0.2
1 (mm)
”Case 1”
[Retainer at Full Lock Position] Raise the terminal retainer up to the temporary lock
position.
Terminal
Stopper Retainer
14
YARIS (EM02C4EL)
C
Tool
Tab
Tab
”Case 1”
Type where terminal retainer is pulled
up to the temporary lock position (Pull
Type).
Retainer
at Temporary Lock Position
[Male] [Female]
Tool Tool
Press Down
[Male] Press Down [Female]
15
YARIS (EM02C4EL)
C TROUBLESHOOTING
Push the terminal retainer down to the temporary lock position.
Retainer at
Full Lock Position
Retainer at
Temporary Lock Position
[Male] [Female]
Locking Lug (c) Release the locking lug from terminal and pull the terminal out
from rear.
Tool
16
YARIS (EM02C4EL)
ABBREVIATIONS D
ABBREVIATIONS
The following abbreviations are used in this manual.
* The titles given inside the components are the names of the terminals (terminal codes) and are not treated as being
abbreviations.
17
YARIS (EM02C4EL)
E GLOSSARY OF TERMS AND SYMBOLS
BATTERY GROUND
Stores chemical energy and The point at which wiring attaches to
converts it into electrical energy. the Body, thereby providing a return
Provides DC current for the auto’s path for an electrical circuit; without a
various electrical circuits. ground, current cannot flow.
CIGARETTE LIGHTER
An electric resistance heating 2. DOUBLE
FILAMENT
element.
18
YARIS (EM02C4EL)
E
RELAY SPEAKER
Basically, an electrically operated An electromechanical device which
1. NORMALLYswitch which may be normally creates sound waves from current
CLOSED closed (1) or open (2). flow.
Current flow through a small coil
creates a magnetic field which either
opens or closes an attached switch.
2. NORMALLY SWITCH, MANUAL
OPEN Opens and closes
circuits, thereby
1. NORMALLY
OPEN stopping (1) or
allowing (2) current
flow.
RELAY, DOUBLE THROW
A relay which passes current 2. NORMALLY
through one set of contacts or the CLOSED
other.
SHORT PIN
WIRES
Used to provide an unbroken
Wires are always drawn as
connection within a junction block. (1) NOT straight lines on wiring
CONNECTED diagrams.
Crossed wires (1) without a
black dot at the junction are
SOLENOID not joined;
An electromagnetic coil which forms crossed wires (2) with a
a magnetic field when current flows, (2) SPLICED black dot or octagonal ( )
to move a plunger, etc. mark at the junction are
spliced (joined)
connections.
19
YARIS (EM02C4EL)
F RELAY LOCATIONS
[Engine Compartment]
(LHD)
Engine ECU Fusible Link Block Skid Control ECU with Actuator
Engine Room
R/B No.2
(RHD)
Fusible Link Block Engine ECU Skid Control ECU with Actuator
Engine Room
R/B No.2
20
YARIS (EM02C4EL)
F
[Instrument Panel]
(LHD)
Power Steering * 1:Before Oct. 2009
ECU Production
* 2:From Oct. 2009
Production
Main Body
ECU
Fuse Block
(*2)
J/B No.6
Instrument
Panel J/B
Front Fog Shift Lock
Light Relay Control ECU
Rear Fog
Light Relay Airbag Sensor
J/B No.5 A/C Amplifier Assembly Center
(RHD)
ID Code Box (*1)
Transponder Key ECU (*2) Power Steering
ECU
21
YARIS (EM02C4EL)
F RELAY LOCATIONS
[Body]
22
YARIS (EM02C4EL)
Memo
23
YARIS (EM02C4EL)
F RELAY LOCATIONS
1 : Engine Room R/B
Engine Compartment Left (See Page 20)
: Engine Room J/B
ABS2/VSC2
2 30A 1
1
5 3 HTR SUB1
2 /AC MG
*8 *7
Relay
2 1 2 4 1 *1
2 1
5 5 *3 *2
EFI
3 3 2 1
Unit A 1 20A 2 1 2
*4
1 2
HAZ
2 10A 1
*5
HORN ETCS
1 10A 2 2 10A 1
1 2
ALT-S
2 7.5A 1
*6
ECU-B
2 7.5A 1
1 2
DOME
2 15A 1
AM2 S-LOCK
1 15A 2 2 20A 1
ST
2 30A 1
H-LP MAIN
2 30A 1
1E 1D
1 1
Unit B
24
YARIS (EM02C4EL)
F
1
2
3
4
1
2
1A 5
3 6
4 7
8
5
6
7 (from Engine Room
8 Main Wire)
1
2
1 3
2
1B 4
3
4 5
6
5 7
6 8
7
8
(from Engine Room
Main Wire)
1C
1
1
Unit A
25
YARIS (EM02C4EL)
F RELAY LOCATIONS
[Engine Room R/B and Engine Room J/B Inner Circuit]
Unit A 1 1A
EFI Relay
1 2
4 1A
20A EFI
3 1A
2 1A
5 1A
HORN Relay
1 2
8 1A
10A HORN
7 1A
6 1A
1 1B
IG2 Relay
1 2
4 1B
15A AM2
3 1B
2 1B
5 1B
FAN NO.1 Relay
8 1B
7 1B
6 1B
1 1C
26
YARIS (EM02C4EL)
F
Unit B
1 2
1
30A ABS2/VSC2
1 2
1
30A RDI
1 2
1
40A HTR
1 2
1
50A ABS1/VSC1
1 2
1 1E 1
50A EPS
1 2
1
*1
(HID Type) 1 2
1 1
(*3)
*2
1 2
1
10A HAZ
1 2
1
10A ETCS
1 2
1
7.5A ALT-S
1 2
1
7.5A ECU-B
1 2
1
15A DOME
1 2
1
20A S-LOCK
1 2
1
30A ST
1 2
1 1D 1
30A H-LP MAIN
27
YARIS (EM02C4EL)
F RELAY LOCATIONS
2 : Engine Room R/B No.2 Engine Compartment Right (See Page 20)
H-LP/AMT Relay
3 5
28
YARIS (EM02C4EL)
F
7 : Engine Room R/B No.7 Engine Compartment Right (See Page 20)
DIM Relay
H-LP Relay
1 2
1 2
H-LP HI RH
2 10A 1
H-LP HI LH
2 10A 1
29
YARIS (EM02C4EL)
F RELAY LOCATIONS
LHD : Lower Finish Panel (See Page 21)
: Instrument Panel J/B
RHD : Instrument Panel Left (See Page 21)
4J 4
3
3 1
4
4K 1 1 2
8 7 6 5 4 1
5
6 2 5 3 5 4 3 3 2 1
(from Instrument
(from Roof Wire) 2 2
Panel Wire)
30A POWER
(for High Current)
1 2 3
4F
4 5 6 7 8
30A DEF
(for High Current)
(from Instrument
Panel Wire)
4L 4G (LHD) (RHD) 4R
IG 1 Relay 1 HTR Relay 1 FLASHER Relay Black
3 21
87654
(from Engine Room
Main Wire) (from Engine Room (from Instrument
Main Wire) Panel Wire)
30
YARIS (EM02C4EL)
F
1
2
3
4
5
6
7
8
Main Body ECU 9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
26
(from Instrument
(from Instrument Panel Wire)
Panel Wire)
4S 4P
123456789 1 2 3 4 5
101112131415161718 6 7 8 9 10
31
YARIS (EM02C4EL)
F RELAY LOCATIONS
LHD : Lower Finish Panel (See Page 21)
: Instrument Panel J/B
RHD : Instrument Panel Left (See Page 21)
RR DOOR
RL DOOR
D DOOR
RR FOG
PANEL1
ID/UP
ACC
MET
7.5A
7.5A
7.5A
7.5A
7.5A
7.5A
20A
20A
20A
15A
CIG
10A
IGN
A/C
*1
FR FOG
TAIL (*2)
RR WIP
GAUGE
ECU-IG
OBD2
STOP
WSH
7.5A
AM1
WIP
20A
15A
15A
10A
10A
10A
25A
15A
25A
D/L
10A
32
YARIS (EM02C4EL)
Memo
33
YARIS (EM02C4EL)
F RELAY LOCATIONS
[Instrument Panel J/B Inner Circuit]
10 4A
29 4A
15 4B
18 4S 17 4A
24 4E PWR Relay 2 4H
1 2
21 4B 11 4H
30A POWER
9 4A
1 4A
12 4A 20A RL DOOR
25 4B 19 4A
20A D DOOR 20A RR DOOR
4 4E 10 4H
12 4C 6 4K
3 4J 10A ID/UP
DEF Relay 11 4M
17 4B 1 2
2 4F
35 4B 30A DEF
12 4Q 4 4Q
13 4A 13 4Q
23 4B 25A D/L
2 4J
8 4E
13 4E 2 4A
12 4D 25A AM1
1 4F
34
YARIS (EM02C4EL)
F
(Cont’d)
30 4E
10A STOP
14 4E 18 4B
17 4E 7.5A OBD2
5 4S
28 4E 7.5A RR FOG
2 4M
12 4E
8 4M
7 4M
6 4M
1 4K
15A FR FOG
15 4A 9 4M
1 4S 5 4M
2 4E (RHD)
4 1 4R
3 5
7 4F 1 4L
1 2
5 4Q 10 4B
31 4B HTR Relay 6 4D
16 4S 15 4S
(LHD) 2 1 (LHD)
28 4A LR IG 19 4B
(LHD) 4 5 (LHD)
32 4B +B EL 11 4S
(LHD) 6 7 (LHD) (RHD)
12 4S ER GND 5 4R
(LHD) 8 3 (LHD)
17 4S EHW LL 27 4A
(RHD)
2 4R 14 4B
(RHD) FLASHER Relay
4 4R 13 4S
(RHD) (RHD)
6 4R 3 4R
(RHD)
8 4R Noise Filter (RHD)
7 4R
5 3
7 4S
10A ECU-IG
2 1 24 4B
3 4F
3 4K
IG 1 Relay
36 4B
20A WIP
1 4H
14 4S
15A WSH
2 4B 32 4E
5 4D 10 4D
10A GAUGE
19 4E 2 4P
11 4C 1 4P
35
YARIS (EM02C4EL)
F RELAY LOCATIONS
[Instrument Panel J/B Inner Circuit]
(Cont’d)
15A RR WIP
25 4A
11 4Q
10 4Q
1 4Q
29 4B
10 4S
7.5A A/C
10 4M 22 4B
8 4F 30 4A
25 4E 23 4E
1 4J C/OPN Relay 20 4E
11 4B 8 4A
1 4D 5 4E
9 4B
15 4C
21 4E
7.5A IGN
27 4B 4 4F
16 4E
7.5A MET
1 4M
12 4M 5 4F
15A CIG
3 4Q
7.5A ACC
4 4S
6 4S
14 4D
36
YARIS (EM02C4EL)
F
(Cont’d)
9 4E
4 4K
16 4C
21 19 13 25 1 4 5
34 4B
ACC TRLY PWS HAZ GND1 ALTB IG
16 4B
4 4J 14 4C
20
10 4C PCTY 24 4A
14 4H 6 4C
10 26
5 4H UL1 DCTY 21 4A
2 4K 26 4E
7
27 4E ILE 5 4A
22
11 4E RRCY 20 4A
13 4H 2 4S
12
4 4H L1 30 4B
3 4A 12 4H
6
17 4H ECUB 3 4D
2
8 4H ACT+ 18 4E
Main Body ECU 15
8 4C HORN 28 4B
8 4D 7 4D
26 4B 6 4E
9
4 4D KSW 4 4C
2 4D 15 4H
2 4C 6 4H
24 16
5 4C PKB UL2 22 4A
17
9 4D LIN1 18 4H
23
7 4A BCTY 9 4H
3
1 4E ACT- 4 4A
7 4E 18 4A
3 4S 16 4H
14
31 4E L2 7 4H
37
YARIS (EM02C4EL)
F RELAY LOCATIONS
D1
2 6 6 2
5 5B 5
4 4
1 3 3 1
38
YARIS (EM02C4EL)
F
[J/B No.5 Inner Circuit]
1 5A 1 5B
2 5A 2 5B
3 5A 3 5B
4 5A 4 5B
5 5A 5 5B
6 5A 6 5B
D1
39
YARIS (EM02C4EL)
F RELAY LOCATIONS
D2
6 2
2 6
5 6A
5
4
4
3 1
1 3
40
YARIS (EM02C4EL)
F
[J/B No.6 Inner Circuit]
1 6A 1 6B
2 6A 2 6B
3 6A 3 6B
4 6A 4 6B
5 6A 5 6B
6 6A 6 6B
D2
41
YARIS (EM02C4EL)
F RELAY LOCATIONS
Fusible Link Block Engine Compartment Left (See Page 20)
Battery
120A ALT
60A MAIN (for High Current)
(for High Current)
C30
1
Battery
A27
A28 Black
1 1 2 1
1 2
42
YARIS (EM02C4EL)
F
[Fusible Link Block Inner Circuit]
1
C
1
A
1
Battery B
120A ALT
2
B
60A MAIN
43
YARIS (EM02C4EL)
F RELAY LOCATIONS
Fuse Block Instrument Panel Left (See Page 21)
D43
44
YARIS (EM02C4EL)
Memo
45
YARIS (EM02C4EL)
G ELECTRICAL WIRING ROUTING
Position of Parts in Engine Compartment
[LHD]
A3 A21 A34 A28 A27 A10 A9
A2
A1
A11
A7 (*4)
A38
(*1)
B1 (*1)
B8
(*2)
B18 (*2)
B24
B4 (*3)
A15
(*1)
B3
B13
(*2)
B20
B6
B14
A37
A4 (*1)
B7
A5 (*2)
B22
B9
B15
A24
A1 Turn Signal Lamp (Front Side RH) B1 Turn Signal Lamp (Front RH)
A2 Turn Signal Lamp (Front Side LH) B2 Horn
A3 Pressure SW B3 Clearance Lamp (RH)
A4 Rear Washer Motor B4 Headlamp (RH)
A5 Windshield Washer Motor B6 Headlamp (LH)
A6 Airbag Sensor (Front RH) B7 Clearance Lamp (LH)
A7 Speed Sensor (Front RH) B8 Turn Signal Lamp (Front LH)
A8 Cooling Fan Motor B9 Fog Lamp (Front RH)
A9 Windshield Wiper Motor B10 Fog Lamp (Front LH)
A10 Brake Fluid Level Warning SW B13 Junction Connector
A11 Speed Sensor (Front LH) B14 Headlamp Leveling Motor (RH)
A12 Airbag Sensor (Front LH) B15 Headlamp Leveling Motor (LH)
A14 Radiator Fan Resistor B18 Turn Signal Lamp (Front RH)
A15 Skid Control ECU with Actuator B20 Clearance Lamp (RH)
A21 Engine ECU B22 Clearance Lamp (LH)
A24 Junction Connector B24 Turn Signal Lamp (Front LH)
A27 Fusible Link Block
A28 Fusible Link Block
A33 Engine Hood Courtesy SW
A34 Security Horn
A37 Junction Connector
A38 Skid Control ECU with Actuator
46
YARIS (EM02C4EL)
G
Position of Parts in Engine Compartment
[LHD]
C4 C20 C11 C5 C12 C13 C6 C14 C7 C30 C36 C3 C26
(*1)
C25
C19
(*2)
C37
C22
C24
C17
P1
C29
C10
C28
C9
C27
C16
47
YARIS (EM02C4EL)
G ELECTRICAL WIRING ROUTING
Position of Parts in Instrument Panel
[LHD Before Jan. 2009 Production]
D18 D25 D31 D13 D8 D19 D2 D36 D1 D35 D34
D38
D39
D33
D32
D12
D10
D15
D11
48
YARIS (EM02C4EL)
G
Position of Parts in Instrument Panel
[LHD Before Jan. 2009 Production]
D44
D74
D43
D42
D40
D45
D41
D72 D46
49
YARIS (EM02C4EL)
G ELECTRICAL WIRING ROUTING
Position of Parts in Instrument Panel
[LHD Before Jan. 2009 Production]
A19 E10 E1
E4
E3
50
YARIS (EM02C4EL)
G
Position of Parts in Instrument Panel
[LHD Before Jan. 2009 Production]
c1 b1 V2 W1 Q1
J8 J9
51
YARIS (EM02C4EL)
G ELECTRICAL WIRING ROUTING
Position of Parts in Instrument Panel
[LHD From Jan. 2009 Production]
D18 D25 D31 D13 D8 D19 D2 D36 D1 D35 D34
D38
D39
D33
D32
D12
D11
D15
D10
52
YARIS (EM02C4EL)
G
Position of Parts in Instrument Panel
[LHD From Jan. 2009 Production]
D97 D93 D53
D44
D74
(*1)
D43
D42
D40
D96
D45
D95
(*2)
D43
D89
D41
53
YARIS (EM02C4EL)
G ELECTRICAL WIRING ROUTING
Position of Parts in Instrument Panel
[LHD From Jan. 2009 Production]
A19
54
YARIS (EM02C4EL)
G
Position of Parts in Instrument Panel
[LHD From Jan. 2009 Production]
c1 b1 V2 W1 Q1
J8 J9
55
YARIS (EM02C4EL)
G ELECTRICAL WIRING ROUTING
Position of Parts in Body
[LHD]
(*1) (*2)
F6 F4 K1 F2 F9 F1 K2 F5 H1 M1 H2 H3
(*1)
G2 O1
(*2)
G9 H4
G1 N1
G8 N6
G5 Z1
G6 N3
N2
N7
56
YARIS (EM02C4EL)
G
Position of Parts in Body
[LHD]
J31 J1 J20
J32
J3
J13
J38
57
YARIS (EM02C4EL)
G ELECTRICAL WIRING ROUTING
Position of Parts in Engine Compartment
[RHD]
(*5) (*6)
A9 A36 A10 A34 A28 A27 A21 A15 A38 B13
A1
A2
A30
A11
A7 (*3)
B8
(*3)
B1 (*4)
B25
(*4)
B19
B17
B16 (*1)
A25
B4
B6
(*3)
B3 (*2)
A37
(*4)
B21 (*3)
B7
B14 (*4)
B23
A4
B15
A5
A24
* 1:w/ ABS
* 2:w/o ABS
B9 * 3:Before Jan. 2009 Production
* 4:From Jan. 2009 Production
* 5:Before Oct. 2009 Production
A6 A3 A33 A8 B2 A12 A14 B10 * 6:From Oct. 2009 Production
A1 Turn Signal Lamp (Front Side RH) B1 Turn Signal Lamp (Front RH)
A2 Turn Signal Lamp (Front Side LH) B2 Horn
A3 Pressure SW B3 Clearance Lamp (RH)
A4 Rear Washer Motor B4 Headlamp (RH)
A5 Windshield Washer Motor B6 Headlamp (LH)
A6 Airbag Sensor (Front RH) B7 Clearance Lamp (LH)
A7 Speed Sensor (Front RH) B8 Turn Signal Lamp (Front LH)
A8 Cooling Fan Motor B9 Fog Lamp (Front RH)
A9 Windshield Wiper Motor B10 Fog Lamp (Front LH)
A10 Brake Fluid Level Warning SW B13 Junction Connector
A11 Speed Sensor (Front LH) B14 Headlamp Leveling Motor (RH)
A12 Airbag Sensor (Front LH) B15 Headlamp Leveling Motor (LH)
A14 Radiator Fan Resistor B16 Headlamp Assembly (RH)
A15 Skid Control ECU with Actuator B17 Headlamp Assembly (LH)
A21 Engine ECU B19 Turn Signal Lamp (Front RH)
A24 Junction Connector B21 Clearance Lamp (RH)
A25 Junction Connector B23 Clearance Lamp (LH)
A27 Fusible Link Block B25 Turn Signal Lamp (Front LH)
A28 Fusible Link Block
A30 Wireless Door Lock Buzzer
A33 Engine Hood Courtesy SW
A34 Security Horn
A36 Option Connector
A37 Junction Connector
A38 Skid Control ECU with Actuator
58
YARIS (EM02C4EL)
G
Position of Parts in Engine Compartment
[RHD]
C4 C11 C5 C12 C13 C6 C14 C7 C18 C30 C36 C20
P1
(*3)
C25
(*4)
C37
C26
C24
C3
C9
C23
C10
C22
C8
C19
C2
59
YARIS (EM02C4EL)
G ELECTRICAL WIRING ROUTING
Position of Parts in Instrument Panel
[RHD Before Jan. 2009 Production]
(*2) (*2)
D33 D11 D25 D2 D32 D7 D23 D6 D1 D3 D36 D31 D37 D38 D39 D24
D35
D34
D10
D5
D18
D14
D28
D16
D21
60
YARIS (EM02C4EL)
G
Position of Parts in Instrument Panel
[RHD Before Jan. 2009 Production]
(*1) (*1)
D48 D66 D65 D64 D46 D44 D58 D71 D47
D40
(*2)
D45
D67
(*1)
D73
D60
D43
D74
D72
D52
D41
D42
61
YARIS (EM02C4EL)
G ELECTRICAL WIRING ROUTING
Position of Parts in Instrument Panel
[RHD Before Jan. 2009 Production]
E1 A26 A19 A13 A35
E10
E4
E3
E2 E6 E5 E8 A16 A20
62
YARIS (EM02C4EL)
G
Position of Parts in Instrument Panel
[RHD Before Jan. 2009 Production]
Q1 V2 b1 c1
J8 J9 W1
63
YARIS (EM02C4EL)
G ELECTRICAL WIRING ROUTING
Position of Parts in Instrument Panel
[RHD From Jan. 2009 Production]
(*2) (*2)
D33 D11 D25 D2 D32 D7 D23 D6 D1 D3 D36 D31 D37 D38 D39 D24
D35
D34
D10
D5
D18
D14
D28
D16
D21
64
YARIS (EM02C4EL)
G
Position of Parts in Instrument Panel
[RHD From Jan. 2009 Production]
(*1) (*1)
D48 D66 D65 D64 D46 D44 D53 D93 D97 D58 D71 D47
D40
(*2)
D45
(*1)
D73
D67
D43
D60
D72
D74
D41
D42
D88
D96
D95
D89
65
YARIS (EM02C4EL)
G ELECTRICAL WIRING ROUTING
Position of Parts in Instrument Panel
[RHD From Jan. 2009 Production]
A26 A19 A13 A35
A16 A20
66
YARIS (EM02C4EL)
G
Position of Parts in Instrument Panel
[RHD From Jan. 2009 Production]
Q1 V2 b1 c1
J8 J9 W1
67
YARIS (EM02C4EL)
G ELECTRICAL WIRING ROUTING
Position of Parts in Body
[RHD]
(*1) (*2)
F6 F8 K1 F2 F9 F7 K2 R1 R2 F5 M1 H1 H2 H4 H3
(*1)
G2
O1
(*2)
G9
N1
G7
N3
G5
N6
G4
N7
G6
Z1
N2
68
YARIS (EM02C4EL)
G
Position of Parts in Body
[RHD]
J34 J31 J1 J20
J32
J3
J28
J37
J4
J38
J36
69
YARIS (EM02C4EL)
G ELECTRICAL WIRING ROUTING
: Location of Connector Joining Wire Harness and Wire Harness
: Location of Ground Points
[LHD]
BA1
A1
Engine Wire
A2
C1 C2 B1
CP1
70
YARIS (EM02C4EL)
Memo
71
YARIS (EM02C4EL)
G ELECTRICAL WIRING ROUTING
: Location of Connector Joining Wire Harness and Wire Harness
[LHD Before Jan. 2009 Production]
AD1 AD5 AA2 DE1 Instrument Panel DQ2 Instrument Panel Wire
Wire Assembly
Roof Wire
Instrument Panel
AE1 No.2 Wire
JD2 FD2
AD4
FD1
JD1
Floor Wire
Floor Wire
Front Door LH
Wire GD2 GD1 AD3 AD2 Engine Room Main Wire
A3
D2
D1
72
YARIS (EM02C4EL)
G
: Location of Connector Joining Wire Harness and Wire Harness
[LHD From Jan. 2009 Production]
AD1 AD5 AA2 Instrument Panel DQ2 Instrument Panel Wire
Wire Assembly
Roof Wire
JD2 FD2
AD4
FD1
JD1
Floor Wire
Floor Wire
Front Door LH
Wire GD2 GD1 AD3 AD2 Engine Room Main Wire
A3
D2
D1
73
YARIS (EM02C4EL)
G ELECTRICAL WIRING ROUTING
: Location of Connector Joining Wire Harness and Wire Harness
: Location of Ground Points
[LHD]
J1
Rear Window
No.1 Wire
O1
Roof Wire
ZJ1
Front Door
LH Wire Skid Control
Sensor RH Wire
MN1
Back Door
No.1 Wire
74
YARIS (EM02C4EL)
Memo
75
YARIS (EM02C4EL)
G ELECTRICAL WIRING ROUTING
: Location of Connector Joining Wire Harness and Wire Harness
: Location of Ground Points
[RHD]
CA1
Engine Room
No.2 Wire
BA1
A1
Engine Wire
A2
B1
C1 C2
CP1
76
YARIS (EM02C4EL)
Memo
77
YARIS (EM02C4EL)
G ELECTRICAL WIRING ROUTING
: Location of Connector Joining Wire Harness and Wire Harness
[RHD Before Jan. 2009 Production]
JD2 AJ1 AD4 AE1 AD5 AD1 Instrument Panel DE2 DE1
Wire Assembly
Roof Wire
DQ2
AA1 Front Door
RH Wire
Front Door
LH Wire
FD1
Floor Wire
GD1 GD2 Instrument Panel Wire Floor Wire Engine Room Main Wire
A3
D1
D2
78
YARIS (EM02C4EL)
G
: Location of Connector Joining Wire Harness and Wire Harness
[RHD From Jan. 2009 Production]
JD2 AJ1 AD4 AD6 AD5 AD1 Instrument Panel
Wire Assembly
Roof Wire
JD1
AD3
AD2 FD2
AA2
DQ2
Front Door
Front Door RH Wire
LH Wire
Floor Wire FD1
GD1 GD2 Instrument Panel Wire Floor Wire Engine Room Main Wire
A3
D1
D2
79
YARIS (EM02C4EL)
G ELECTRICAL WIRING ROUTING
: Location of Connector Joining Wire Harness and Wire Harness
: Location of Ground Points
[RHD]
Front Door FR1 MJ1 Electrical Key HJ1 Rear Door No.1
RH Wire Wire Harness RH Wire
J1
Front Door O1
LH Wire
ZJ1
Back Door
No.2 Wire
N1
MN1
Floor Wire
Skid Control
Sensor RH Wire
80
YARIS (EM02C4EL)
Memo
81
YARIS (EM02C4EL)
H SYSTEM CIRCUITS
YARIS
ELECTRICAL WIRING DIAGRAM
SYSTEM CIRCUITS
Page
ABS (Before Oct. 2009 Production) .................................................................. 198
ABS (From Oct. 2009 Production) .................................................................... 204
Air Conditioner (Before Jan. 2009 Production) ............................................... 300
Air Conditioner (From Jan. 2009 Production) ................................................. 306
Audio System ..................................................................................................... 286
Back-Up Light ..................................................................................................... 178
Charging .............................................................................................................. 108
Cigarette Lighter ................................................................................................. 284
Combination Meter ............................................................................................. 290
Cooling Fan ......................................................................................................... 298
DLC3 .................................................................................................................... 140
Door Lock Control (LHD) ................................................................................... 230
Door Lock Control (RHD) .................................................................................. 236
ECT and A/T Indicator ........................................................................................ 132
Engine Control .................................................................................................... 114
Engine Immobiliser System (w/o Smart Entry & Start System) ..................... 128
EPS ...................................................................................................................... 216
Front Fog Light ................................................................................................... 182
Front Wiper and Washer .................................................................................... 270
Headlight (Except HID Type) ............................................................................. 150
Headlight (HID Type) .......................................................................................... 146
Headlight Beam Level Control .......................................................................... 154
Horn ..................................................................................................................... 190
Ignition ................................................................................................................ 110
Illumination ......................................................................................................... 172
Interior Light ....................................................................................................... 166
Key Reminder (w/o Smart Entry & Start System) ............................................ 192
Light Reminder ................................................................................................... 194
Multiplex Communication System (CAN) ........................................................ 142
Power Outlet ....................................................................................................... 284
Power Source ..................................................................................................... 84
Power Window (LHD) ......................................................................................... 222
Power Window (RHD) ........................................................................................ 226
Rear Fog Light .................................................................................................... 186
Rear Window Defogger ...................................................................................... 282
Rear Wiper and Washer ..................................................................................... 274
Remote Control Mirror ....................................................................................... 278
Seat Belt Warning ............................................................................................... 214
Shift Lock ............................................................................................................ 276
82
YARIS (EM02C4EL)
H
Page
Smart Entry & Start System .............................................................................. 92
* Engine Immobiliser
* Push-Button Start
* Steering Lock
* Wireless Door Lock Control
SRS ...................................................................................................................... 209
Starting (w/o Smart Entry & Start System) ...................................................... 106
Stop Light ............................................................................................................ 180
Taillight ................................................................................................................ 172
Theft Deterrent (LHD) ......................................................................................... 254
Theft Deterrent (RHD) ........................................................................................ 262
Turn Signal and Hazard Warning Light (LHD) ................................................. 158
Turn Signal and Hazard Warning Light (RHD) ................................................. 162
Wireless Door Lock Control (LHD) ................................................................... 242
Wireless Door Lock Control (RHD w/o Smart Entry & Start System) ............ 248
83
YARIS (EM02C4EL)
Power Source
W W
7. 5A ALT–S
1
1 2
1D
15A DOME
Alternator
1 2 L L
1
C10
B (∗2) (∗2)
1
30A ST
W
B
1 2
7. 5A ECU–B
1 C 1 A 1 B 2 B
1 2
A27(B), A28(A), C30(C)
10A ETCS
60A MAIN
120A ALT
1 2
10A HAZ
1 2
B(∗3)
B(∗3)
(∗4) 1 2
20A S–LOCK
1 2 1 2
7
84
YARIS (EM02C4EL)
B B
50A EPS
1
B B 1 2
1E
1 2 1 2
1 2 1 2
IG2 Relay
GR
15A AM2 30A ABS2/VSC2 (∗1)
1
W 1 2 1 2
1C
3 1B 2 1B 4 1B 1 1B
30A RDI
1 2 P
(∗1)
GR
W
P
L
(∗2)
14 AA2
P
GR
(∗1)
P
(∗1)
10A H–LP HI LH
(∗2)
W
W–B
1 2
10A H–LP HI RH
W 1 2
7
(∗3)
GR GR
(∗2) (∗2)
15A H–LP LO LH P
(∗2)
1 2
L
(∗2)
15A H–LP LO RH
B 1 2
1
(∗3)
A1
85
YARIS (EM02C4EL)
Power Source
B B
1 6 G G
C AM1 IG1D C
(∗1) (∗1)
BE(∗1 ∗9)
(∗1 ∗10)
O
4 4 LG
ACCD F B
(∗1)
(∗7)
(∗8)
6 Y
GR 5 7 SB 6 6 9 L
F B AM2 SSW2 C (∗1)
(∗1) (∗1) (∗1)
(∗7)
(∗8)
D36
Junction
(∗1)
(∗1)
LG
10
Y
Connector R
SSW1 C
(∗1)
P 5
C IG2D 7 2
(∗1)
SS1 SS2
2 5
ACC Relay
Free
D73
1 3
Full
Traveling
Power SW
GND COM D55
5 4
W–B
W–B
W–B
(∗1)
(∗1)
(∗1)
(∗1)
L
W–B W–B
(∗1) (∗1)
GR GR
(∗2) (∗2)
W W
P P
(∗2) (∗2)
L L
(∗2) (∗2)
L
W–B
W–B
(∗1)
(∗1)
(∗1)
D2 D1
86
YARIS (EM02C4EL)
B B
Y Y
(∗1) (∗1)
Y
(∗2)
G
ACC 2 W(∗2) (∗1)
(∗2)
4 1 3 2
W
W 7. 5A ACC2 B
GR 5 AM2 IG2 6 P A B A B
(∗2) (∗2)
(LHD)
(RHD)
(LHD)
(RHD)
(∗2) (∗2)
ST2
8 4S 2 A 3 A (∗10)
2 B 3 B (∗9)
D8
Ignition SW D45(A), (B)
ACC Cut Relay
13 4B
1 A 4 A (∗10)
1 B 4 B (∗9)
(∗2)
(∗2)
G
L
18 AD4
(∗2)
G
13 L
ACCR (∗2)
A21
GR Engine ECU
(∗2)
W W
P
(∗2)
L
(∗2)
L L
(∗1) (∗1)
87
YARIS (EM02C4EL)
Power Source
7. 5A PANEL1
T–LP Relay
30A DEF
1 2 10A ID/UP
15A FR FOG
DEF Relay
Y 7. 5A OBD2
(∗1)
1 (∗6) 10A TAIL (∗6) 4
Y W
4F 4M
(∗2) (∗6)
10A STOP
G
20A D DOOR
(∗1) 30A POWER
PWR Relay
3
G 1 2
4F
(∗2)
25A D/L
20A RL DOOR
7. 5A RR FOG
Noise Filter
IG 1 Relay
5 3 10A ECU–IG
2 1 20A WIP
15A WSH
5 7. 5A ACC
L
4F
(∗2) 10A GAUGE
15A CIG
15A RR WIP
4 7. 5A MET
W
4F
7. 5A A/C
7. 5A IGN
17 4E
W–B
L
(∗1)
D2
88
YARIS (EM02C4EL)
∗ 1 : w/ Smart Entry & Start System
∗ 2 : w/o Smart Entry & Start System
∗ 5 : w/ Theft Deterrent System
∗ 6 : w/o Theft Deterrent System
W
(∗6)
5
B1
B1 T1
Light OFF D4
Control Headlamp Dimmer SW
SW Tail Assembly
Head
T1
8
10 7. 5A PANEL2 7. 5A PANEL1
G
4E
(∗6)
89
YARIS (EM02C4EL)
Power Source
: Parts Location
Code See Page Code See Page Code See Page
46 (LHD) D4 64 (*4) 49 (*1)
A21 A
58 (RHD) 48 (*1) 61 (*3)
D45
42, 46 (LHD) 52 (*2) 53 (*2)
A27 B D8 B
42, 58 (RHD) 60 (*3) 65 (*4)
42, 46 (LHD) 64 (*4) 61 (*3)
A28 A D55
42, 58 (RHD) 48 (*1) 65 (*4)
47 (LHD) 52 (*2) B 61 (*3)
C10 D36
59 (RHD) 60 (*3) D64 61 (*3)
F
42, 47 (LHD) 64 (*4) 65 (*4)
C30 C
42, 59 (RHD) 44, 49 (*1) 61 (*3)
A D65 C
48 (*1) 44, 53 (*2) 65 (*4)
D43
D4 52 (*2) 44, 61 (*3) 61 (*3)
B D73
60 (*3) 44, 65 (*4) 65 (*4)
: Relay Blocks
Code See Page Relay Blocks (Relay Block Location)
1 24 Engine Room R/B (Engine Compartment Left)
7 29 Engine Room R/B No.7 (Engine Compartment Right)
*1: LHD Before Jan. 2009 Production *2: LHD From Jan. 2009 Production *3: RHD Before Jan. 2009 Production
*4: RHD From Jan. 2009 Production
90
YARIS (EM02C4EL)
: Ground Points
Code See Page Ground Points Location
70 (LHD)
A1 Left Suspension Tower
76 (RHD)
72 (*1)
73 (*2)
D1 Left Kick Panel
78 (*3)
79 (*4)
72 (*1)
73 (*2)
D2 Right Kick Panel
78 (*3)
79 (*4)
*1: LHD Before Jan. 2009 Production *2: LHD From Jan. 2009 Production *3: RHD Before Jan. 2009 Production
*4: RHD From Jan. 2009 Production
91
YARIS (EM02C4EL)
Smart Entry & Start System
2 2
W 1 21 4E 18 4B 1 1B
GR
B
B
1 1 2
Stop Lamp SW
4 AD2
5 2
A13
1
ST
Relay GR
G
3 1 A25(A), A37(B)
Junction 15 A (∗1) G
Connector 15 B (∗2)
1 1 GR
17 A 16 A (∗1)
12 B 14 B (∗2)
R
W–B
GR
BR
W
V
Y
V
5
13 AA2
B L
Park/Neutral
Position SW
P
Y
1 B
1 N
C27
A25(A), A37(B)
A
4 1 A (∗1)
Connector
1 B (∗2)
Junction
GR
M
2 A (∗1)
B
2 B (∗2)
C1(A), C15(B) 10 CA2
Starter
GR
Battery BR
∗ 1 : w/ ABS
∗ 2 : w/o ABS
∗ 3 : From Jan. 2008 Production
W–B
A1
92
YARIS (EM02C4EL)
D64(B), (F), D65(C), D66(D)
Main Body ECU
GR
SB
G
B
BE(∗5)
O(∗6)
24 4E 9 AD4 18 AD4
BE(∗5)
Connector
O(∗6)
6 A 7 A
Junction
G
B
D36(A)
5 A 12 4B
GR
G
GR
R
GR
R
R GR A21(A), C20(B)
14 A 13 A Engine ECU
STSW ACCR
2 5
ST Cut Relay
52 B 48 A 122 B 121 B 15 A 11 A 10 A
1 3
BE(∗5)
(Shielded)
P
L
(∗5)
(∗6)
O(∗6)
BR
BE
O
BE(∗5)
1
O(∗6)
8 CA1 5 AA2
W–B
Position Sensor
Crankshaft
(∗5)
(∗6)
C2
BR
BE
BE(∗5)
1 AD4 12 AA2
O(∗6)
BE W
(∗5)
LG
O
(∗6)
BR
W–B
BR
D1 C1
93
YARIS (EM02C4EL)
Smart Entry & Start System
M
2
P
3 4
R
IGE SLP1
9 AD2
IG2 SGND GND LIN B
6 2 1 5 7
R
P
P
D58(A), (B) 3 B (∗3)
ID Code Box 3 A (∗4)
LIN1
(∗6)
BE
W
O
17 AD4 8 AD4
W–B
W–B
W–B
W
BE(∗5)
O(∗6)
L
W
LG
LG
W–B
W–B
3 6A 6 6A
D1 D2
94
YARIS (EM02C4EL)
D64(B), (F), D65(C), D66(D)
Main Body ECU
CANL CANH
16 D 15 D
(BAT)
W
30 4B 2 4S 3 4D
7. 5A
ECU–B
D42
L
16 5 Junction Connector
2
1
25
L
17 6 18 7 AA2
GR
W
G
21 E 20 E 2 E (∗8)
21 C 20 C 2 C (∗7)
21 A 20 A 2 A (∗4)
Electronic Key
CAN I/F Display
CAN Controller
GR
P P
LG LG
95
YARIS (EM02C4EL)
Smart Entry & Start System
L
12 4HP 8 4R
7 A
D34(A)
Junction
B
W–B
Connector
P
Connector
11 A 5 A
Junction
D36(A)
LG
9 A 8
HAZ 11 B (∗3)
11 A (∗4)
13 AD4 P2
B
D71
LG
Turn Signal
Flasher
D22(A), (B)
Shift Lock
Control ECU
W–B W–B
1
+B
D60
Certification ECU
GR
GR
W
W
R
P
W
R
L
W–B
W–B
W–B
GND
J13
A30
1
GR
2
W
W–B
W–B
LG
W–B
W–B
D1 D2 A2 J2
96
YARIS (EM02C4EL)
D64(B), (F), D65(C), D66(D)
Main Body ECU
SB
LG
R
Y
L
7 2 13 12 11
SS1 SS2 INDW INDS SWIL
Transponder Key Coil
Free
Full
Traveling
W–B
BR
P
(∗5)
(∗6)
BE
O
W–B W–B
40 8 9 30
AGND TXCT CODE VC5
D60
Certification ECU
97
YARIS (EM02C4EL)
Smart Entry & Start System
SB
LG
V
P
6 JD1 7 JD1 3 JD1 4 JD1
LG
SB
LG
V
11 12 15 16 31 32
CLG5 CG5B CLG7 CG7B CLG8 CG8B
D60
Certification ECU
V
7 FD2 4 FD2 5 FD2 6 FD2 15 FD2 3 FD2
BE(∗5)
R
O(∗6)
W
L
7 FR1 6 FR1 4 FR1 3 FR1 2 FR1 1 FR1
W
O
R
B
3 6 5 2 1 9 8 3 2 4 6 10 5 1
TRG+ SGT ANT1 ANT2 TRG– TRG– ANT2 ANT1 SGT SEL SENS CLG CLGB +B
GND
R1 R2 7
Door Outside Handle (Front RH) Electrical Key Oscillator (Front Door RH)
BR
2 6B
D2
98
YARIS (EM02C4EL)
D64(B), (F), D65(C), D66(D)
Main Body ECU
Y
2 4K
10A 7. 5A 15A
ECU–IG ACC DOME
9 JD1 2
P
BR
BR
Y
7 4S 6 4S
GR
R
L
8 B 13 B
D36(A), D37(B) D34(A), D35(B)
BR
Junction Junction
Y
Connector Connector
4 A 20 A 13 4B
BR
13 MN1 14 MN1
BR
18 19 7 4 4P 5 4K
IG ACC TSW5
D60
BR
Certification ECU
L
SECO SECI IND
L
1
25 24 2
4 1
Luggage Electrical Key SW
Room Lamp(Center)
UL B
LG
(∗5)
(∗6)
BE
DOOR
Opener
LOCK
OFF
Junction Connector
ON
Connector
17 B 1 B
D38(A), D39(B)
Junction
25 24
D35(B)
K2
BRK– BRK+ 2 3
16 B E L
N6
9 A
W–B
3 2
P
LG
W–B
W–B
D74
Theft Warning ECU
2
V
W–B
D25
Security
Indicator Lamp
6
W–B
D2 N1
99
YARIS (EM02C4EL)
Smart Entry & Start System
7 4A
21 4A 24 4A 20 4A 5 4A
(∗5)
(∗6)
BE
SB
G
R
Connector
6 B
Junction
8 JD1
J29(B)
5 B
1 A (∗9) 1 A (∗9) 1 A (∗9) 1 A (∗9)
Door Courtesy SW
Door Courtesy SW
Door Courtesy SW
Door Courtesy SW
1 B (∗8) 1 B (∗8) 1 B (∗8) 1 B (∗8)
(∗5)
(∗6)
BR
BE
O
J32(A), (B)
J33(A), (B)
(Front RH)
(Front LH)
(Rear RH)
(Rear LH)
J1(A), (B)
J2(A), (B)
3 MJ1 12 MJ1
BR
B
3 MN1 15 MN1
(∗5)
(∗6)
BR
BE
4 2
Back Door Lock Assembly
Courtesy
M
N2
W–B
N1
100
YARIS (EM02C4EL)
D64(B), (F), D65(C), D66(D)
Main Body ECU
9 4H 17 4H 18 4H 8 4H
(∗5)
(∗6)
SB
BE
W
O
P
L
L
9 GD1 20 GD1 10 GD1 9 FD1 20 FD1 10 FD1
(∗5)
(∗6)
(∗5)
(∗6)
BE
BE
O
O
P
P
L
8 1 4 7 1 4
LSSR UL L LSSR UL L
Detection
Detection
Unlock
Unlock
M M
E E
7 G5 8 F5
Door Lock Assembly (Front LH) Door Lock Assembly (Front RH)
W–B
W–B
1 5B 1 6B
D1 D2
101
YARIS (EM02C4EL)
Smart Entry & Start System
(BAT)
3 4A 4 4A 17 4E
W–B
GR
J28(A), J29(B)
8 B 2 B Junction Connector
11 A 5 A 12 A 6 A
GR
GR
P
GR
P
4 1 4 1
L UL L UL
M M
H3 I3
Door Lock Door Lock Assembly
Assembly (Rear LH)
(Rear RH)
W–B
D2
102
YARIS (EM02C4EL)
: Parts Location
Code See Page Code See Page Code See Page
62 (*3) 60 (*3) D71 65 (*4)
A13 D38 A
66 (*4) 64 (*4) 61 (*3)
D74
A21 A 58 (RHD) 60 (*3) 65 (*4)
D39 B
A25 A 58 (RHD) 64 (*4) F5 68 (RHD)
A30 58 (RHD) 61 (*3) G5 68 (RHD)
D42
A37 B 58 (RHD) 65 (*4) H3 68 (RHD)
C1 A 59 (RHD) 61 (*3) I3 68 (RHD)
D55
C2 59 (RHD) 65 (*4) A 69 (RHD)
J1
C15 B 59 (RHD) 61 (*3) B 69 (RHD)
D56
C20 B 59 (RHD) 65 (*4) A 69 (RHD)
J2
C27 59 (RHD) A 61 (*3) B 69 (RHD)
A 60 (*3) D58 61 (*3) J13 69 (RHD)
B
60 (*3) 65 (*4) J28 A 69 (RHD)
D1 C
64 (*4) 61 (*3) J29 B 69 (RHD)
D60
E 64 (*4) 65 (*4) A 69 (RHD)
J32
A 60 (*3) A 61 (*3) B 69 (RHD)
D22 60 (*3) D61 61 (*3) A 69 (RHD)
B B J33
64 (*4) 65 (*4) B 69 (RHD)
60 (*3) B 61 (*3) A 69 (RHD)
D25 J36
64 (*4) D64 61 (*3) B 69 (RHD)
F
60 (*3) 65 (*4) J37 69 (RHD)
D34 A
64 (*4) 61 (*3) K2 68 (RHD)
D65 C
60 (*3) 65 (*4) N2 68 (RHD)
D35 B
64 (*4) 61 (*3) N6 68 (RHD)
D66 D
60 (*3) 65 (*4) R1 68 (RHD)
D36 A
64 (*4) 61 (*3) R2 68 (RHD)
D67
60 (*3) 65 (*4)
D37 B
64 (*4) D71 61 (*3)
: Relay Blocks
Code See Page Relay Blocks (Relay Block Location)
1 24 Engine Room R/B (Engine Compartment Left)
*1: LHD Before Jan. 2009 Production *2: LHD From Jan. 2009 Production *3: RHD Before Jan. 2009 Production
*4: RHD From Jan. 2009 Production
103
YARIS (EM02C4EL)
Smart Entry & Start System
: Connector Joining Wire Harness and Wire Harness
Code See Page Joining Wire Harness and Wire Harness (Connector Location)
AD2 79 (*4)
78 (*3) Engine Room Main Wire and Instrument Panel Wire (Instrument Panel Left)
AD4
79 (*4)
CA1
76 (RHD) Engine Wire and Engine Room Main Wire (Engine Compartment Left)
CA2
78 (*3)
FD1
79 (*4)
Front Door RH Wire and Instrument Panel Wire (Right Kick Panel)
78 (*3)
FD2
79 (*4)
FR1 80 (RHD) Front Door RH Wire and Electrical Key Wire RH (Right Door Panel)
78 (*3)
GD1 Front Door LH Wire and Instrument Panel Wire (Left Kick Panel)
79 (*4)
HJ1 80 (RHD) Rear Door No.1 Wire and Floor Wire (Right Center Pillar)
IJ1 80 (RHD) Rear Door No.2 Wire and Floor Wire (Left Center Pillar)
78 (*3)
JD1 Floor Wire and Instrument Panel Wire (Instrument Panel Left)
79 (*4)
MJ1 80 (RHD) Back Door No.1 Wire and Floor Wire (Left Rear Quarter Panel)
MN1 80 (RHD) Back Door No.1 Wire and Back Door No.2 Wire (Back Door Panel Center)
: Ground Points
Code See Page Ground Points Location
A1
76 (RHD) Left Suspension Tower
A2
C1 76 (RHD) Engine Block Left
78 (*3)
D1 Left Kick Panel
79 (*4)
78 (*3)
D2 Right Kick Panel
79 (*4)
78 (*3)
D3 Instrument Panel Reinforcement Right
79 (*4)
J2 80 (RHD) Left Rear Quarter Panel
N1 80 (RHD) Back Door Panel Center
*1: LHD Before Jan. 2009 Production *2: LHD From Jan. 2009 Production *3: RHD Before Jan. 2009 Production
*4: RHD From Jan. 2009 Production
104
YARIS (EM02C4EL)
Memo
105
YARIS (EM02C4EL)
Starting (w/o Smart Entry & Start System)
∗ 1 : RHD w/ ABS
(BAT) (BAT) (BAT) ∗ 2 : LHD, RHD w/o ABS
∗ 3 : From Jan. 2009 Production
∗ 4 : Before Jan. 2009 Production
30A 15A 15A
ST DOME AM2
5 AM2 IG2
2 2 2
ST2 7
1 1 1 1B
D8
GR
GR
Ignition SW
W
B
13 4B
4 AD2
W
P
2 A 3 A (∗4)
8 4S 2 B 3 B (∗3)
D45(A), (B)
ACC Cut
1 Relay
1 A 4 A (∗4)
1 B 4 B (∗3)
5 2
L
ST
Relay 18 AD4 9 AD4
B
3 1
Diode (Starter)
A21(A), C20(B) 13 A 14 A 1
ACCR STSW
Engine ECU
1 1
D44
1
STA STAR
W–B
2
V
48 A 52 B
B
A25(A), A37(B)
15 A (∗1)
Connector
(∗3)
(∗4)
BE
SB
Junction
O
15 B (∗2)
BR
(A/T)
(∗3) (∗4)
BR
W
O
B
(∗4)
BE
W
V
1 B 5
(∗4)
1
O
1 BE
Clutch Start SW
A B L C27
Park/Neutral (∗3)
7 5
P Position SW
A16
M N
2 6 D36
B
4 Junction
GR
Connector
C1(A), C15(B)
Starter
(A/T)
GR
10 AD4
10 CA2
Y
(M/T)
Y
13 AA2
Battery
(A/T)
GR
3 A 2 A 1 A (∗1)
3 B 2 B 1 B (∗2)
A25(A), A37(B)
A1 Junction
Connector
106
YARIS (EM02C4EL)
: Parts Location
Code See Page Code See Page Code See Page
50 (*1) 47 (LHD) 52 (*2)
C15 B
54 (*2) 59 (RHD) D36 60 (*3)
A16
62 (*3) 47 (LHD) 64 (*4)
C20 B
66 (*4) 59 (RHD) 49 (*1)
46 (LHD) 47 (LHD) 53 (*2)
A21 A C27 D44
58 (RHD) 59 (RHD) 61 (*3)
A25 A 58 (RHD) 48 (*1) 65 (*4)
46 (LHD) 52 (*2) 49 (*1)
A37 B D8 A
58 (RHD) 60 (*3) 61 (*3)
D45
47 (LHD) 64 (*4) 53 (*2)
C1 A B
59 (RHD) D36 48 (*1) 65 (*4)
: Relay Blocks
Code See Page Relay Blocks (Relay Block Location)
1 24 Engine Room R/B (Engine Compartment Left)
: Ground Points
Code See Page Ground Points Location
70 (LHD)
A1 Left Suspension Tower
76 (RHD)
*1: LHD Before Jan. 2009 Production *2: LHD From Jan. 2009 Production *3: RHD Before Jan. 2009 Production
*4: RHD From Jan. 2009 Production
107
YARIS (EM02C4EL)
Charging
W
(IG) (IG)
1 1D
GAUGE
7. 5A
MET
10A
1
ALT–S
7. 5A
1 4M 19 4B
B
1
∗ 1 : From Jan. 2008 Production until Oct. 2009 Production 1 E (∗3)
∗ 2 : Before Jan. 2008 Production
1 C (∗1)
∗ 3 : From Oct. 2009 Production
G
Combination Meter
W
Charge
1 CA1
1 F (∗3)
1 D (∗1)
5 CA1 1 B (∗2)
C20
Engine ECU
L
ALT 15 AD3
50
(RHD)
W
G
P
(LHD)
7 AA2
L
W
(RHD)
L
2 B 1 C
Fusible Link Block
4 CA1
60A MAIN
A27(B), C30(C)
120A ALT
C9(A), C10(B)
Alternator 1 B 3 A 1 A 4 A 2 A
B M S L IG
Battery
IC Regulator
108
YARIS (EM02C4EL)
: Parts Location
Code See Page Code See Page Code See Page
42, 46 (LHD) C30 C 42, 59 (RHD) 48 (*1)
A27 B B
42, 58 (RHD) 48 (*1) 60 (*3)
A
47 (LHD) 60 (*3) 48 (*1)
C9 A
59 (RHD) 48 (*1) 52 (*2)
D2 D
47 (LHD) 52 (*2) 60 (*3)
C10 B D1 C
59 (RHD) 60 (*3) 64 (*4)
47 (LHD) 64 (*4) 52 (*2)
C20 F
59 (RHD) 52 (*2) 64 (*4)
E
C30 C 42, 47 (LHD) 64 (*4)
: Relay Blocks
Code See Page Relay Blocks (Relay Block Location)
1 24 Engine Room R/B (Engine Compartment Left)
*1: LHD Before Jan. 2009 Production *2: LHD From Jan. 2009 Production *3: RHD Before Jan. 2009 Production
*4: RHD From Jan. 2009 Production
109
YARIS (EM02C4EL)
Ignition
GR
(∗1) (BAT)
GR
15A
(∗2) AM2
D8
Ignition SW
2
5 AM2 IG2 6 P
(∗2)
ST2
5 5 AD4 4 AD2 R
D36
Junction Connector
(∗1)
7
R
P
P
(∗1)
SB
14 AA2 11 CA1
6 F (∗3)
6 B (∗4)
GR
R
P
AM2 D64(B), (F), D65(C)
Main Body ECU
IG2D
5 C 2 1B 1 1B 4 1B
(∗1)
P
IG2
Relay
3 1B
W–B
A1
110
YARIS (EM02C4EL)
∗ 1 : w/ Smart Entry & Start System
∗ 2 : w/o Smart Entry & Start System
∗ 3 : From Jan. 2008 Production
∗ 4 : Before Jan. 2008 Production
∗ 5 : From Jan. 2009 Production
∗ 6 : Before Jan. 2009 Production
R R
1 A (∗6)
C25(A), C37(B)
R 1 B (∗5)
Noise Filter
(Ignition)
BR LG
R
GND IGT IGF IGF IGT2 GND IGF GND IGT3 IGF GND IGT4
4 3 2 2 3 4 2 4 3 2 4 3
BE(∗5)
O(∗6)
W–B
W–B
W–B
W–B
LG
W
G
Y
Y Y
W–B W–B
W–B
85 81 84 83 82
IGT1 IGF1 IGT2 IGT3 IGT4
C20
Engine ECU
C1
111
YARIS (EM02C4EL)
Ignition
: Parts Location
Code See Page Code See Page Code See Page
47 (LHD) 47 (LHD) 60 (*3)
C11 C25 A D36
59 (RHD) 59 (RHD) 64 (*4)
47 (LHD) 47 (LHD) 61 (*3)
C12 C37 B B
59 (RHD) 59 (RHD) 65 (*4)
D64
47 (LHD) 48 (*1) 61 (*3)
C13 F
59 (RHD) 52 (*2) 65 (*4)
D8
47 (LHD) 60 (*3) 61 (*3)
C14 D65 C
59 (RHD) 64 (*4) 65 (*4)
47 (LHD) 48 (*1)
C20 D36
59 (RHD) 52 (*2)
: Ground Points
Code See Page Ground Points Location
70 (LHD)
A1 Left Suspension Tower
76 (RHD)
70 (LHD)
C1 Engine Block Left
76 (RHD)
*1: LHD Before Jan. 2009 Production *2: LHD From Jan. 2009 Production *3: RHD Before Jan. 2009 Production
*4: RHD From Jan. 2009 Production
112
YARIS (EM02C4EL)
Memo
113
YARIS (EM02C4EL)
Engine Control
(BAT) (BAT)
5 AM2 IG2 6 P
20A 15A
EFI AM2 (∗2)
ST2 7 B
(∗2) 9
B
2 2 AD4
D8
Ignition SW
EFI IG2
Relay Relay
(∗1)
B
AM2 IG2D
6 F (∗7) 5 C
6 B (∗8)
W–B
W–B
(∗2)
(∗2)
GR
GR
GR
R
Y
P
(∗1)
SB
14 AA2 11 CA1
Connector
Junction
R
P
D36
5
(∗1)
(∗1)
GR
P
4 AD2 5 AD4
GR
B
W–B
W–B
114
YARIS (EM02C4EL)
P
B B
BR
1
(IG)
B
5 2
7. 5A A25(A), A37(B)
15 A (∗5) Junction 17 A (∗5)
IGN
C/OPN ST 15 B (∗6) Connector 12 B (∗6)
Relay Relay
3 1 18 A 16 A (∗5)
13 B 14 B (∗6)
27 4B 9 4B 5 4E 11 4B 8 4A
1
(A/T)
W
(M/T)
W–B
R
P
B
9 CA1
(A/T)
W
Fuel Suction Pump and
Park/Neutral Position SW
4 1 5
Clutch Start SW
Gage Assembly
B L
Pump
M
P
A16
J5
5 2 N
C27
W–B
GR(A/T)
Y(M/T)
GR GR
Y Y
R R
B B B B
W–B
W–B
J1 A1
115
YARIS (EM02C4EL)
Engine Control
(BAT)
10A
STOP
P
18 4B
BR
B
13 AA2 10 AD4
GR 3 A 2 A (∗12)
(∗1) 4 B 2 B (∗11)
(∗1)
(∗2)
GR
BR
R
Y
A13(A), (B)
Stop
2 5 6
Connector
A25(A), A37(B) Lamp SW
Junction
Junction 1 A (∗5)
D67
D36
Connector 1 B (∗6) 5 AA2 4 A 1 A (∗12)
ST Cut
Relay 7 3 B 1 B (∗11)
2 A 3 A (∗5) 1 3
(∗2 ∗11)
(∗2 ∗12)
BR
3 B (∗6)
G
2 B
Y
BE
O
BE(∗1 ∗11)
W–B
(∗1)
O(∗1 ∗12) 48 A 14 A 35 A 36 A
(M/T)
(A/T)
GR
(∗12)
BE
GR
BE(∗11)
R
V
Y
(∗12)
O
GR(A/T) BE(∗11)
Y(M/T) O(∗12)
V V
GR
R R
B B
116
YARIS (EM02C4EL)
(BAT) ∗ 1 : w/ Smart Entry & Start System
∗ 2 : w/o Smart Entry & Start System
∗ 5 : RHD w/ ABS
10A ∗ 6 : LHD, RHD w/o ABS
ETCS ∗11 : From Jan. 2009 Production
∗12 : Before Jan. 2009 Production
C19
THW
2
24 AA2
GR
L
3 A 96 B 97 B
+BM ETHW THW
A21(A), C20(B)
Engine ECU
# 40 # 30 # 20 # 10
105 B 106 B 107 B
GR 108 B
SB
P
L
BR
LG
R
Fuel Injector (No. 1)
1 1 1 1
C4
C5
C6
C7
2 2 2 2
R
GR
SB
B B
117
YARIS (EM02C4EL)
Engine Control
W W
(BAT) (∗4) (∗4)
120A ALT
13 A (LHD)
A28
Fusible 5 B (RHD)
Link Block 4 4M B1
1 B1 T1
Head
(∗3)
(∗4)
(∗3) (∗4) T1
D4(A), (B) 10 A (LHD)
Headlamp Dimmer SW 8 B (RHD)
1 4G 15 4B 10 4E Assembly
G
(∗4)
31 A
ELS
A21(A), C20(B)
Engine ECU
+B2 +B IMI IMO PRG
1 A 2 A 11 A 10 A 49 B
B
L
(∗11)
(∗12)
BE
W
O
8 AD4 17 AD4 1
VSV (Purge)
C3
2
(∗1 ∗11)
(∗1 ∗12)
BE
(∗2 ∗11)
O
(∗2)
BE
W
(∗2 ∗12)
(∗1)
W
O
6 B 5 B (∗7)
13 12 6 A 5 A (∗8)
EFIO EFII EFIO EFII
V
W(∗7)
1 12
B B V V V B(∗8)
AA2 CA1
9 5
B B B
AA2 AD5
118
YARIS (EM02C4EL)
∗ 1 : w/ Smart Entry & Start System
∗ 2 : w/o Smart Entry & Start System
∗ 3 : w/ Theft Deterrent System
∗ 4 : w/o Theft Deterrent System
∗ 7 : From Jan. 2008 Production
∗ 8 : Before Jan. 2008 Production
∗11 : From Jan. 2009 Production
∗12 : Before Jan. 2009 Production
C17
Throttle Body Assembly
E2 VC VTA VTA2 M+ M–
3 5 6 4 2 1
(Shielded)
GR
W
R
V
BR
91 B 67 B 115 B 114 B 42 B 41 B 63 B
ETA VCTA VTA1 VTA2 M+ M– GE01
A21(A), C20(B)
Engine ECU
THA E2G VG ETHA HT1A EX1A OX1A HT1B EX1B
65 B 116 B 118 B 88 B 109 B 90 B 112 B 47 B 87 B
GR
LG
5 CA2 4 CA2
(Shielded)
BE(∗11)
O(∗12)
GR
LG
W
G
P
GR
LG
4 2 3 5 1 4 3
THA E2G VG E2 HT1A E2 OX1A 4 AD5 3 AD5
Oxygen Sensor (Bank 1 Sensor 2)
+B +B
GR
LG
1 C26 2 C36
Air Flow Meter Oxygen Sensor
(Bank 1 Sensor 1) 1 4
HT1B E2
B
D28
+B OX1B
2 3
W(∗7)
B
B(∗8) B W
(Shielded)
119
YARIS (EM02C4EL)
Engine Control
D99(C), E8(A), (B)
A/C Amplifier
AC1 ACT
17 B 19 B (∗13)
17 A 19 A (∗8)
17 C 19 C (∗11)
(∗12)
(∗12)
R
B
FAN NO. 2 Relay
Ignition Coils
(∗11)
(∗11)
R
B
11 DE1 3 DE1
(∗12)
(∗12)
R
B
8 AD5 9 AD5
B
BE(∗11)
O(∗12)
LG
LG
W
21 AA2 20 AA2
B
85 B 84 B 83 B 82 B 81 B 22 A 30 A 18 A
IGT1 IGT2 IGT3 IGT4 IGF1 FAN2 AC1 ACT
A21(A), C20(B)
Engine ECU
OX1B KNK1 EKNK NE+ NE– G2+
64 B 110 B 111 B 122 B 121 B 99 B
P
(Shielded)
(Shielded)
G
G
R
(Shielded)
W
P
B
L
(Shielded)
B
Knock Control Sensor
2
Crankshaft Position
Camshaft Position
1 AD5 2 AD5 1 2
(Bank 1)
Sensor
Sensor
(Shielded)
C18
C2
P1
W
2 1
1
(Shielded)
BR
C1
120
YARIS (EM02C4EL)
(BAT)
30A
DEF
2
11 4M
DEF
Relay
10A
ID/UP
V
2 AD4 (LHD, RHD ∗11)
8 AD3 (RHD ∗12)
∗ 8 : Before Jan. 2008 Production
∗11 : From Jan. 2009 Production
∗12 : Before Jan. 2009 Production
∗13 : From Jan. 2008 Production until Jan. 2009 Production
V
33 A
ELS3
A21(A), C20(B)
Engine ECU
OC1+ OC1– EC E1 ME01 E01 E03 ALT
100 B 123 B 32 A 104 B 43 B 45 B 86 B 50 B
P
3
M
W–B
BR
BR
BR
Camshaft Timing Oil Control Valve
W
R
C9
Alternator
1
C24
A1 C2
121
YARIS (EM02C4EL)
Engine Control
A20
Accelerator Position Sensor
BR
W
G
R
B
L
58 A 56 A 60 A 57 A 55 A 59 A
VCP2 VPA2 EPA2 VCPA VPA EPA
A21(A), C20(B)
Engine ECU
E02 TC TACH SPD CANL CANH W
44 B 27 A 15 A 8 A 49 A 41 A 24 A
LG
W
B
B
L
LG
(∗1)
Junction Connector
12 4D 8 4C
W
B
L
5
SB
D34
(∗2)
LG
6
P
15 4
Connector
Junction
D41
BE
(∗1 ∗11) 22 11
O
(∗1 ∗12)
13 9 B
TC TAC
D15 W
DLC3
SB
C1
122
YARIS (EM02C4EL)
(IG) (BAT)
16 AA2 (LHD) L 2 4S
25 AA2 (RHD)
B
L
1 E 2 E (∗15)
1 C 2 C (∗14)
1 A 2 A (∗8)
5V IC
Check Engine
CPU
CAN Controller
D1(A), (C), (E), D2(B), (D), (F)
Combination Meter
4 F 20 E 21 E 24 E 16 E 17 E (∗15)
4 D 20 C 21 C 24 C 16 C 17 C (∗14)
4 B 20 A 21 A 24 A 16 A 17 A (∗8)
P
BR
SB
W
G
B
11 AD3
7 18 P
Connector
Junction
(∗10)
(∗9)
D42
11 22
26 A (∗16) A15(A), A38(B)
B 22 B (∗15) Skid Control ECU with Actuator
SP1
Y
FL+ FL– FR+ FR– RL+ RL– RR+ RR–
9 A 8 A 31 A 30 A 11 A 12 A 33 A 34 A (∗16)
W 19 B 18 B 7 B 6 B 5 B 4 B 17 B 16 B (∗15)
(∗9)
(∗9)
(∗9)
(∗9)
(∗9)
(∗9)
(∗9)
(∗9)
LG
G
R
SB
D3
Speed Sensors
123
YARIS (EM02C4EL)
Engine Control
10A
ECU–IG
24 4B
(∗10)
B
16 B
A37(B)
Junction
Connector
20 B
(∗10)
B
P W–B
(∗10) (∗10)
(∗10)
(∗10)
W–B
P
3 1 2
SI IG+ SE
(∗10)
W–B
C23
Speed Sensor
A1
124
YARIS (EM02C4EL)
: Parts Location
Code See Page Code See Page Code See Page
50 (*1) 47 (LHD) 60 (*3)
A C20 B D28
62 (*3) 59 (RHD) 64 (*4)
A13
54 (*2) C23 59 (RHD) 48 (*1)
B
66 (*4) 47 (LHD) 52 (*2)
C24 D34
46 (LHD) 59 (RHD) 60 (*3)
A15 A
58 (RHD) 47 (LHD) 64 (*4)
C26
50 (*1) 59 (RHD) 48 (*1)
54 (*2) 47 (LHD) 52 (*2)
A16 C27 D36
62 (*3) 59 (RHD) 60 (*3)
66 (*4) 47 (LHD) 64 (*4)
C36
50 (*1) 59 (RHD) 49 (*1)
54 (*2) 48 (*1) 53 (*2)
A20 A D41
62 (*3) 60 (*3) 61 (*3)
66 (*4) 48 (*1) 65 (*4)
46 (LHD) 52 (*2) 49 (*1)
A21 A D1 C
58 (RHD) 60 (*3) 53 (*2)
D42
A25 A 58 (RHD) 64 (*4) 61 (*3)
42, 46 (LHD) 52 (*2) 65 (*4)
A28 E
42, 58 (RHD) 64 (*4) A 61 (*3)
46 (LHD) 48 (*1) D58 61 (*3)
A37 B B B
58 (RHD) 60 (*3) 65 (*4)
46 (LHD) 48 (*1) 61 (*3)
A38 B B
58 (RHD) 52 (*2) 65 (*4)
D2 D D64
47 (LHD) 60 (*3) 61 (*3)
C2 F
59 (RHD) 64 (*4) 65 (*4)
47 (LHD) 52 (*2) 61 (*3)
C3 F D65 C
59 (RHD) 64 (*4) 65 (*4)
47 (LHD) 48 (*1) 61 (*3)
C4 A D66 D
59 (RHD) 52 (*2) 65 (*4)
D4
47 (LHD) 60 (*3) 61 (*3)
C5 B D67
59 (RHD) 64 (*4) 65 (*4)
47 (LHD) 48 (*1) 53 (*2)
C6 D99 C
59 (RHD) 52 (*2) 65 (*4)
D8
47 (LHD) 60 (*3) 50 (*1)
C7 A
59 (RHD) 64 (*4) 62 (*3)
E8
47 (LHD) 48 (*1) 50 (*1)
C9 B
59 (RHD) 52 (*2) 62 (*3)
D15
47 (LHD) 60 (*3) 57 (LHD)
C17 J5
59 (RHD) 64 (*4) 69 (RHD)
47 (LHD) 60 (*3) 47 (LHD)
C18 D23 P1
59 (RHD) 64 (*4) 59 (RHD)
47 (LHD) 48 (*1)
C19 D28
59 (RHD) 52 (*2)
: Relay Blocks
Code See Page Relay Blocks (Relay Block Location)
1 24 Engine Room R/B (Engine Compartment Left)
*1: LHD Before Jan. 2009 Production *2: LHD From Jan. 2009 Production *3: RHD Before Jan. 2009 Production
*4: RHD From Jan. 2009 Production
125
YARIS (EM02C4EL)
Engine Control
: Junction Block and Wire Harness Connector
Code See Page Junction Block and Wire Harness (Connector Location)
30 (LHD) Engine Room Main Wire and Instrument Panel J/B (Lower Finish Panel)
4B
30 (RHD) Engine Room Main Wire and Instrument Panel J/B (Instrument Panel Left)
30 (LHD) Instrument Panel Wire and Instrument Panel J/B (Lower Finish Panel)
4C
30 (RHD) Instrument Panel Wire and Instrument Panel J/B (Instrument Panel Left)
30 (LHD) Instrument Panel Wire and Instrument Panel J/B (Lower Finish Panel)
4D
30 (RHD) Instrument Panel Wire and Instrument Panel J/B (Instrument Panel Left)
30 (LHD) Instrument Panel Wire and Instrument Panel J/B (Lower Finish Panel)
4E
30 (RHD) Instrument Panel Wire and Instrument Panel J/B (Instrument Panel Left)
30 (LHD) Engine Room Main Wire and Instrument Panel J/B (Lower Finish Panel)
4G
30 (RHD) Engine Room Main Wire and Instrument Panel J/B (Instrument Panel Left)
31 (LHD) Instrument Panel Wire and Instrument Panel J/B (Lower Finish Panel)
4M
31 (RHD) Instrument Panel Wire and Instrument Panel J/B (Instrument Panel Left)
31 (LHD) Instrument Panel Wire and Instrument Panel J/B (Lower Finish Panel)
4S
31 (RHD) Instrument Panel Wire and Instrument Panel J/B (Instrument Panel Left)
: Ground Points
Code See Page Ground Points Location
70 (LHD)
A1 Left Suspension Tower
76 (RHD)
70 (LHD)
C1
76 (RHD)
Engine Block Left
70 (LHD)
C2
76 (RHD)
*1: LHD Before Jan. 2009 Production *2: LHD From Jan. 2009 Production *3: RHD Before Jan. 2009 Production
*4: RHD From Jan. 2009 Production
126
YARIS (EM02C4EL)
: Ground Points
Code See Page Ground Points Location
72 (*1)
Instrument Panel Reinforcement Left
73 (*2)
D3
78 (*3)
Instrument Panel Reinforcement Right
79 (*4)
74 (LHD)
J1 Right Rear Quarter Panel
80 (RHD)
*1: LHD Before Jan. 2009 Production *2: LHD From Jan. 2009 Production *3: RHD Before Jan. 2009 Production
*4: RHD From Jan. 2009 Production
127
YARIS (EM02C4EL)
Engine Immobiliser System (w/o Smart Entry & Start System)
(BAT) (IG)
7. 5A 7. 5A
ECU–B IGN
1 21 4E
L
A21(A)
25 AA2 Engine ECU
L
30 4B
IMI IMO
11 A 10 A
12 4H
R
(∗2)
(∗3)
BE
W
O
P
11 A
D36(A), D37(B)
Junction Connector 8 AD4 17 AD4
2 B (∗2)
(∗3)
BE
W
O
L
1 2 13 12
+B IG EFIO EFII
GND IND
D23 16 8
Transponder Key ECU
W–B
(∗1)
LG
D25
Security Indicator
Lamp
6
W–B
(∗1)
W–B
5
D40
Junction
Connector
11
W–B
1 5A
D1
128
YARIS (EM02C4EL)
∗ 1 : w/ Security Indicator Lamp
∗ 2 : From Jan. 2009 Production
∗ 3 : Before Jan. 2009 Production
∗ 4 : Before Oct. 2009 Production
∗ 5 : From Oct. 2009 Production
D24
Transponder Key Amplifier
GR
G
P
D23
Transponder Key ECU 14 15 4 5
VC5 CODE TXCT AGND
KSW CTY D
3 7 9
(∗2)
(∗3)
BE
W
O
4 4C 6 4C 21
D35
Junction Connector
20
7 4D 21 4A
(∗2)
(∗3)
BE
O
Y
3 4S
Unlock Warning SW
7 4E
D19
R
Door Courtesy SW (Front RH)
2
L
1 A (∗4)
1 B (∗5) 7
D15
W–B
SIL DLC3
J1(A), (B)
3 6A
D2
129
YARIS (EM02C4EL)
Engine Immobiliser System (w/o Smart Entry & Start System)
: Parts Location
Code See Page Code See Page Code See Page
46 (LHD) D24 64 (*4) 48 (*1)
A21 A
58 (RHD) 48 (*1) 52 (*2)
D37 B
48 (*1) 52 (*2) 60 (*3)
D25
52 (*2) 60 (*3) 64 (*4)
D15
60 (*3) 64 (*4) 49 (*1)
64 (*4) 48 (*1) 53 (*2)
D40
48 (*1) 52 (*2) 61 (*3)
D35
52 (*2) 60 (*3) 65 (*4)
D19
60 (*3) 64 (*4) 57 (LHD)
A
64 (*4) 48 (*1) 69 (RHD)
J1
60 (*3) 52 (*2) 57 (LHD)
D23 D36 A B
64 (*4) 60 (*3) 69 (RHD)
D24 60 (*3) 64 (*4)
: Relay Blocks
Code See Page Relay Blocks (Relay Block Location)
1 24 Engine Room R/B (Engine Compartment Left)
: Ground Points
Code See Page Ground Points Location
72 (*1)
D1 73 (*2) Left Kick Panel
78 (*3)
*1: LHD Before Jan. 2009 Production *2: LHD From Jan. 2009 Production *3: RHD Before Jan. 2009 Production
*4: RHD From Jan. 2009 Production
130
YARIS (EM02C4EL)
: Ground Points
Code See Page Ground Points Location
D1 79 (*4) Left Kick Panel
72 (*1)
73 (*2)
D2 Right Kick Panel
78 (*3)
79 (*4)
*1: LHD Before Jan. 2009 Production *2: LHD From Jan. 2009 Production *3: RHD Before Jan. 2009 Production
*4: RHD From Jan. 2009 Production
131
YARIS (EM02C4EL)
ECT and A/T Indicator
5 AM2 IG2
15A 7. 5A 10A
AM2 IGN STOP
ST2 7
2
D8
Ignition SW 27 4B 18 4B
1 1B
B
6 F (∗5)
Connector
(∗2)
GR
GR
A13(A), (B)
Junction
(∗2)
Stop Lamp SW
B
D36
STSW
5 4 D
4 A 1 A (∗8)
GR B 3 B 1 B (∗7)
(∗1) (∗1)
G
Y
4 AD2 9 AD4
B
14 A 35 A 36 A
STSW ST1– STP
A21(A), C20(B)
Engine ECU
STA STAR
48 A 52 B
BR
(∗8)
(∗7)
BE
O
5
5 AA2
B L
8 CA1
C27
P Park/Neutral
Position SW
1
BR
N
(∗7)
(∗8)
BE
O
B
4
5 2
15 A 17 A (∗3) 12 AA2 12 AA2
ST 15 B 12 B (∗4)
GR
(∗7)
(∗8)
BE
Relay
O
O
GR
(∗1 ∗8)
(∗2 ∗7)
(∗2 ∗8)
(∗1)
BE
O
R
9 CA1
A25(A), A37(B)
2 A (∗3)
W–B
2 3
Connector
2 B (∗4)
Junction
7
W
D67 D36
ST Cut Junction
1 A (∗3) Relay Connector
1 B (∗4) 6
1 5
W–B
(∗1)
(∗1)
(∗2)
GR
GR
Y
13 AA2
10 AD4
Y
A1
132
YARIS (EM02C4EL)
∗ 1 : w/ Smart Entry & Start System (BAT)
∗ 2 : w/o Smart Entry & Start System
∗ 3 : RHD w/ ABS
∗ 4 : LHD, RHD w/o ABS 10A
∗ 5 : From Jan. 2008 Production ETCS
∗ 6 : Before Jan. 2008 Production
∗ 7 : From Jan. 2009 Production
∗ 8 : Before Jan. 2009 Production 2
1 1
E2
C19
C29
THW 24 AA2
2 2
GR
G
P
B
L
96 B 97 B 3 A 125 B 124 B
ETHW THW +BM NT+ NT–
A21(A), C20(B)
Engine ECU
NE+ NE– G2+ EC E1 ME01 E01 E03
122 B 121 B 99 B 32 A 104 B 43 B 45 B 86 B
P
(Shielded)
(Shielded)
W–B
BR
BR
W
W
P
B
L
Crankshaft Position
Camshaft Position
1 2
Sensor
Sensor
C18
C2
2 1
BR
C1 A1 C2
133
YARIS (EM02C4EL)
ECT and A/T Indicator
A20
Accelerator Position Sensor
BR
W
G
R
B
L
58 A 56 A 60 A 57 A 55 A 59 A
VCP2 VPA2 EPA2 VCPA VPA EPA
A21(A), C20(B)
Engine ECU
E02 TC TACH SPD CANL CANH
44 B 27 A 15 A 8 A 49 A 41 A
LG
W
B
23 4B 13 AD4 26 4B 16 AD4 L
15 AD4
(∗1)
LG
5
Connector
12 4D 8 4C
Junction
D34
(∗2)
LG
6
SB
W
P
L
(∗1 ∗7)
(∗1 ∗8)
BE
13 9 15 4
Connector
Junction
TC TAC
D41
22 11
D15
DLC3
Y
SB
C1
134
YARIS (EM02C4EL)
(IG)
G
10A
GAUGE
1 CA1
19 4B
2
RB
G
Park/Neutral
Position SW
C27
PL RL NL DL 2L LL
6 1 9 7 3 8
L
SB
G
R
L
14 CA1
A21(A), C20(B)
73 B 53 B 54 B 55 B 74 B Engine ECU 56 B
P R N 2 L D
(RHD)
L
S1 S2 SL SLT+ SLT– ST THO1 ETHO ODMS
(LHD)
L
79 B 78 B 57 B 76 B 75 B 80 B 72 B 95 B 26 A 22 AA2
BE(LHD ∗7)
(RHD)
L
O(LHD ∗8)
GR
SB
W
G
P
B
L
(RHD ∗7)
(RHD ∗8)
BE
8 AA2 2 AD3
L
O(LHD ∗8)
Shift Lock Control ECU
5 10 4 3 8 2 1 6 BE(LHD ∗7) 9 B (∗5)
S1 S2 SL SLT+ SLT– ST THO E2 9 A (∗6)
NSSD
GR
LG
W
D22(A), (B)
G
O
B
14 AD3
AT3
3 B (∗5)
3 A (∗6)
BE(∗7)
C28
ECT Solenoid O(∗8)
Y Y
W W
SB SB
135
YARIS (EM02C4EL)
ECT and A/T Indicator
(IG) (BAT)
∗ 6 : Before Jan. 2008 Production
∗ 9 : w/ ABS
7. 5A 7. 5A ∗10 : w/o ABS
MET ECU–B ∗11 : From Jan. 2008 Production until Oct. 2009 Production
∗12 : From Oct. 2009 Production
∗13 : Before Oct. 2009 Production
2
1 4M 1 30 4B
L
16 AA2 (LHD) 2 4S
25 AA2 (RHD)
B
L
1 E 2 E (∗12)
1 C 2 C (∗11) D1(A), (C), (E)
1 A 2 A (∗6) Combination Meter
5V IC
CPU
CAN Controller
20 E 21 E 24 E 16 E 17 E (∗12)
20 C 21 C 24 C 16 C 17 C (∗11)
20 A 21 A 24 A 16 A 17 A (∗6)
P
BR
SB
W
G
11 AD3
P
(∗10)
(∗9)
P
7 18
Connector
Junction
(∗9)
(∗9)
(∗9)
(∗9)
(∗9)
(∗9)
(∗9)
LG
G
R
SB
BR
D3
Speed Sensors
136
YARIS (EM02C4EL)
(IG)
10A
ECU–IG
24 4B
(∗10)
B
16 B
A37(B)
Junction
Connector
20 B
(∗10)
B
P W–B
(∗10) (∗10)
12 CA2
11 CA2 13 CA2 23 AA2
(∗10)
(∗10)
(∗10)
W–B
P
3 1 2
SI IG+ SE
(∗10)
W–B
C23
Speed Sensor
A1
137
YARIS (EM02C4EL)
ECT and A/T Indicator
: Parts Location
Code See Page Code See Page Code See Page
50 (*1) 47 (LHD) 52 (*2)
A C27
62 (*3) 59 (RHD) D22 B 60 (*3)
A13
54 (*2) 47 (LHD) 64 (*4)
B C28
66 (*4) 59 (RHD) 48 (*1)
46 (LHD) 47 (LHD) 52 (*2)
A15 A C29 D34
58 (RHD) 59 (RHD) 60 (*3)
50 (*1) 48 (*1) 64 (*4)
A
54 (*2) 60 (*3) 48 (*1)
A20
62 (*3) 48 (*1) 52 (*2)
D36
66 (*4) 52 (*2) 60 (*3)
D1 C
46 (LHD) 60 (*3) 64 (*4)
A21 A
58 (RHD) 64 (*4) 49 (*1)
A25 A 58 (RHD) 52 (*2) 53 (*2)
E D41
46 (LHD) 64 (*4) 61 (*3)
A37 B
58 (RHD) 48 (*1) 65 (*4)
46 (LHD) 52 (*2) 49 (*1)
A38 B D8
58 (RHD) 60 (*3) 53 (*2)
D42
47 (LHD) 64 (*4) 61 (*3)
C2
59 (RHD) 48 (*1) 65 (*4)
47 (LHD) 52 (*2) B 61 (*3)
C18 D15
59 (RHD) 60 (*3) D64 61 (*3)
F
47 (LHD) 64 (*4) 65 (*4)
C19
59 (RHD) 48 (*1) 61 (*3)
D66 D
47 (LHD) A 60 (*3) 65 (*4)
C20 B D22
59 (RHD) 64 (*4) 61 (*3)
D67
C23 59 (RHD) B 48 (*1) 65 (*4)
: Relay Blocks
Code See Page Relay Blocks (Relay Block Location)
1 24 Engine Room R/B (Engine Compartment Left)
*1: LHD Before Jan. 2009 Production *2: LHD From Jan. 2009 Production *3: RHD Before Jan. 2009 Production
*4: RHD From Jan. 2009 Production
138
YARIS (EM02C4EL)
: Connector Joining Wire Harness and Wire Harness
Code See Page Joining Wire Harness and Wire Harness (Connector Location)
AD2 79 (*4)
72 (*1)
73 (*2)
AD3
78 (*3)
79 (*4) Engine Room Main Wire and Instrument Panel Wire (Instrument Panel Left)
72 (*1)
73 (*2)
AD4
78 (*3)
79 (*4)
70 (LHD)
CA1
76 (RHD)
Engine Wire and Engine Room Main Wire (Engine Compartment Left)
70 (LHD)
CA2
76 (RHD)
: Ground Points
Code See Page Ground Points Location
70 (LHD)
A1 Left Suspension Tower
76 (RHD)
70 (LHD)
C1
76 (RHD)
Engine Block Left
70 (LHD)
C2
76 (RHD)
72 (*1)
Instrument Panel Reinforcement Left
73 (*2)
D3
78 (*3)
Instrument Panel Reinforcement Right
79 (*4)
*1: LHD Before Jan. 2009 Production *2: LHD From Jan. 2009 Production *3: RHD Before Jan. 2009 Production
*4: RHD From Jan. 2009 Production
139
YARIS (EM02C4EL)
DLC3
(BAT)
P
7. 5A
OBD2
13 A
D34(A), D35(B)
W
P
Junction
5 4S Connector
20 B
11 F 2 F (∗3)
11 B 2 B (∗4) 16
(∗5) TS SIL SIL
(∗6)
BE
O Power
Steering
Airbag Sensor
Assembly Center
ECU
31 4E 3 4S
LG
SB
7 4E
L
D66
Main Body ECU
D15
16 7 DLC3 12 TACH
BAT SIL TS 2
(∗1)
L
4 14 6 13 9
(∗1 ∗5)
BE
O(∗1 ∗6)
W
V
W–B
6 A 7 A
(∗2)
LG
P
5 A D34(A)
Connector
12 4D Junction
(∗1)
Junction
LG
Connector
13 AD4
23 4B
A21
Engine ECU
TACH TC
15 27
LG
P
W–B
W–B
D1 D2
140
YARIS (EM02C4EL)
: Parts Location
Code See Page Code See Page Code See Page
46 (LHD) D16 64 (*4) 60 (*3)
A21 D34 A
58 (RHD) 48 (*1) 64 (*4)
B
48 (*1) 60 (*3) 48 (*1)
52 (*2) 48 (*1) 52 (*2)
D15 D31 D35 B
60 (*3) 52 (*2) 60 (*3)
F
64 (*4) 60 (*3) 64 (*4)
48 (*1) 64 (*4) 61 (*3)
D66
D16 52 (*2) 48 (*1) 65 (*4)
D34 A
60 (*3) 52 (*2)
: Ground Points
Code See Page Ground Points Location
72 (*1)
73 (*2)
D1 Left Kick Panel
78 (*3)
79 (*4)
72 (*1)
73 (*2)
D2 Right Kick Panel
78 (*3)
79 (*4)
*1: LHD Before Jan. 2009 Production *2: LHD From Jan. 2009 Production *3: RHD Before Jan. 2009 Production
*4: RHD From Jan. 2009 Production
141
YARIS (EM02C4EL)
Multiplex Communication System (CAN)
Y
SB
W
W
R
16 5 4 15 11 22
D42 6 17 7 18 3 14
Junction Connector
(RHD)
(RHD)
(∗1)
(∗1)
GR
W
G
V
(LHD)
W
20 E 21 E (∗8) (LHD)
20 C 21 C (∗7)
27 28 20 A 21 A (∗4) 6 14
CANH CANL CANH CANL CANH CANL
142
YARIS (EM02C4EL)
∗ 1 : w/ Smart Entry & Start System
∗ 2 : w/o Smart Entry & Start System
∗ 3 : From Jan. 2008 Production
∗ 4 : Before Jan. 2008 Production
∗ 5 : From Jan. 2009 Production
∗ 6 : Before Jan. 2009 Production
∗ 7 : From Jan. 2008 Production until Oct. 2009 Production
∗ 8 : From Oct. 2009 Production
∗ 9 : Before Oct. 2009 Production
D16
Airbag Sensor
Assembly Center
CANH CANL
13 22
W
W B
D41
22 11 Junction Connector 8 19
3 14 15 4 1 12
(LHD)
(LHD)
W
W
G
V
V
(LHD)
W
W
G
L
W
(LHD)
6 A 5 A (∗9)
49 41 25 B 14 B (∗8)
CANL CANH CANH CANL
143
YARIS (EM02C4EL)
Multiplex Communication System (CAN)
: Parts Location
Code See Page Code See Page Code See Page
46 (LHD) 60 (*3) 60 (*3)
A15 A D15 D33 E
58 (RHD) 64 (*4) 64 (*4)
46 (LHD) 48 (*1) 49 (*1)
A21
58 (RHD) 52 (*2) 53 (*2)
D16 D41
46 (LHD) 60 (*3) 61 (*3)
A38 B
58 (RHD) 64 (*4) 65 (*4)
48 (*1) 48 (*1) 49 (*1)
A B
60 (*3) 60 (*3) 53 (*2)
D42
48 (*1) 48 (*1) 61 (*3)
D31
52 (*2) 52 (*2) 65 (*4)
D1 C F
60 (*3) 60 (*3) 61 (*3)
D60
64 (*4) 64 (*4) 65 (*4)
52 (*2) 48 (*1) 61 (*3)
E A D66 D
64 (*4) 60 (*3) 65 (*4)
D33
48 (*1) 48 (*1)
D15 E
52 (*2) 52 (*2)
*1: LHD Before Jan. 2009 Production *2: LHD From Jan. 2009 Production *3: RHD Before Jan. 2009 Production
*4: RHD From Jan. 2009 Production
144
YARIS (EM02C4EL)
Memo
145
YARIS (EM02C4EL)
Headlight (HID Type)
W
7 1
1 1 1 1
2 2 2 2
7 7 1 1
GR
GR
GR
GR
G
B
8 AA2 5 BA1 4 BA1 2 BA1 7 BA1
GR
GR
B
G
B
20 AD3 1 3 1 3
B B B B
Control ECU
Control ECU
Low (HID)
Low (HID)
High
High
14 F (∗3)
Light
Light
14 D (∗1)
14 B (∗2)
B17
B16
HI HI
Combination Meter
2 2
Beam
D2(B), (D), (F)
W–B
W–B
11 F (∗3) W–B
11 D (∗1)
11 B (∗2)
W–B
P
6 BA1
P
W–B
W–B
B1 A1
146
YARIS (EM02C4EL)
(BAT)
30A
H–LP MAIN
W
2
B
1
B
B B
BR
W
7 7 7 7
5 1 5 1
DIM H–LP
Relay Relay
3 2 3 2
7 7 7 7
V
B
B
BR
16 4B 17 4B
16 4C 4 4J 3 4J
6
P
SB 1 D40
Junction
Connector
9 10
HU HL
B1 T1 RF H ED HU HL (H) ED
Dimmer SW
Control SW
OFF Flash
Light
Tail Low
P Head High
ED
D4 7
Headlamp Dimmer SW
Assembly
12 17
W–B W–B
4E 4E
D2
147
YARIS (EM02C4EL)
Headlight (HID Type)
: Parts Location
Code See Page Code See Page Code See Page
B16 58 (RHD) 60 (*3) 60 (*3)
D D4
B17 58 (RHD) 64 (*4) 64 (*4)
D2
48 (*1) 52 (*2) 49 (*1)
B F
60 (*3) 64 (*4) 53 (*2)
D2 D40
48 (*1) 48 (*1) 61 (*3)
D D4
52 (*2) 52 (*2) 65 (*4)
: Relay Blocks
Code See Page Relay Blocks (Relay Block Location)
1 24 Engine Room R/B (Engine Compartment Left)
7 29 Engine Room R/B No.7 (Engine Compartment Right)
: Ground Points
Code See Page Ground Points Location
70 (LHD)
A1 Left Suspension Tower
76 (RHD)
70 (LHD)
B1 Radiator Support Left
76 (RHD)
72 (*1)
73 (*2)
D2 Right Kick Panel
78 (*3)
79 (*4)
*1: LHD Before Jan. 2009 Production *2: LHD From Jan. 2009 Production *3: RHD Before Jan. 2009 Production
*4: RHD From Jan. 2009 Production
148
YARIS (EM02C4EL)
Memo
149
YARIS (EM02C4EL)
Headlight (Except HID Type)
(BAT)
10A
H–LP RH/
H–LP LO RH
GR(∗5)
GR GR(∗2 ∗6)
(∗2 ∗6)
GR GR(∗1 ∗6)
(∗5)
GR
(∗1 ∗6)
8 AA2 B
3 BA1
(∗6)
GR
B4
20 AD3 Headlamp (RH)
2 1
BR BR
L L
GR
14 F (∗7)
14 D (∗3)
14 B (∗4) 7 BA1 4 BA1
Combination Meter
BR
Beam
G
D2(B), (D), (F)
34 4B 16 4B
11 F (∗7)
11 D (∗3)
11 B (∗4)
16 4C 4 4J
P
SB
9 A 8 A (LHD)
9 B 10 B (RHD)
HU HL
B1 T1 RF H ED HU HL (H) ED
Dimmer SW
Control SW
OFF Flash
Light
Tail Low
Head High
ED
D4(A), (B) 11 A (LHD)
Headlamp Dimmer SW 7 B (RHD)
Assembly
12 17
W–B W–B
4E 4E
D2
150
YARIS (EM02C4EL)
(BAT)
GR(∗5)
GR(∗2 ∗6)
GR(∗1 ∗6)
GR
(∗1)
(∗1)
GR
L
6 BA1
2 2
GR
3 5 1
B6
Headlamp (LH) H–LP/AMT
Relay
2 1
BR
3 2
L
G
2 2
(∗1 ∗6)
2 BA1 5 BA1
W–B
(∗1)
(∗1)
(∗1)
GR
V
L
V
(∗1)
L
(∗2)
L
(∗1)
35 4B
(∗2)
V
3 4J 17 4B
Y
6
SB 1 D40 V
Junction
Connector (∗1)
W–B
(∗1)
A1
151
YARIS (EM02C4EL)
Headlight (Except HID Type)
: Parts Location
Code See Page Code See Page Code See Page
46 (LHD) 60 (*3) 48 (*1)
B4 D
58 (RHD) 64 (*4) 52 (*2)
D2 D4 B
46 (LHD) 52 (*2) 60 (*3)
B6 F
58 (RHD) 64 (*4) 64 (*4)
48 (*1) 48 (*1) 49 (*1)
B
60 (*3) 52 (*2) 53 (*2)
D2 D4 A D40
48 (*1) 60 (*3) 61 (*3)
D
52 (*2) 64 (*4) 65 (*4)
: Relay Blocks
Code See Page Relay Blocks (Relay Block Location)
1 24 Engine Room R/B (Engine Compartment Left)
2 28 Engine Room R/B No.2 (Engine Compartment Right)
: Ground Points
Code See Page Ground Points Location
70 (LHD)
A1 Left Suspension Tower
76 (RHD)
72 (*1)
73 (*2)
D2 Right Kick Panel
78 (*3)
79 (*4)
*1: LHD Before Jan. 2009 Production *2: LHD From Jan. 2009 Production *3: RHD Before Jan. 2009 Production
*4: RHD From Jan. 2009 Production
152
YARIS (EM02C4EL)
Memo
153
YARIS (EM02C4EL)
Headlight Beam Level Control
(BAT)
120A ALT
A28
Fusible
Link Block
1
B
1 4G
T–LP
Relay
GR R
LG
R
10A A24(A), B13(B)
TAIL Junction
11 A 10 A 9 A Connector 7 A
Connector
Junction
A24(A)
12 A
9 4S 33 4B
10 B 12 B 9 B 11 B
W
G
R
3 2 3 2
D4 LH T LHM+ RH T RHM+
Headlamp Dimmer SW
Assembly 5
B1
LH E RH E
B15
B14
B1 T1 1 1
OFF
W–B
W–B
Light
Control
SW Tail
W–B
Head
T1
W–B
9 BA1
W–B
W–B
W–B
4 6A
D2 B1
154
YARIS (EM02C4EL)
R
LG
15 AA2 16 AA2
LG
6 AD3 5 AD3
LG
2 1
T B
E
4 D52
Headlamp
Leveling SW
W–B
7 AD3
W–B
10 AA2
W–B
155
YARIS (EM02C4EL)
Headlight Beam Level Control
: Parts Location
Code See Page Code See Page Code See Page
46 (LHD) B13 B 58 (RHD) 48 (*1)
A24 A
58 (RHD) 46 (LHD) 52 (*2)
B14 D4
42, 46 (LHD) 58 (RHD) 60 (*3)
A28
42, 58 (RHD) 46 (LHD) 64 (*4)
B15
B13 B 46 (LHD) 58 (RHD) D52 61 (*3)
: Ground Points
Code See Page Ground Points Location
70 (LHD)
B1 Radiator Support Left
76 (RHD)
72 (*1)
73 (*2)
D2 Right Kick Panel
78 (*3)
79 (*4)
*1: LHD Before Jan. 2009 Production *2: LHD From Jan. 2009 Production *3: RHD Before Jan. 2009 Production
*4: RHD From Jan. 2009 Production
156
YARIS (EM02C4EL)
Memo
157
YARIS (EM02C4EL)
Turn Signal and Hazard Warning Light (LHD)
(BAT) (IG) B
V
10A 10A
HAZ GAUGE
11 4S 12 4S
R
1 5 6
IG EL ER
FLASHER Relay
+B LR LL EHW GND
4 2 3 8 7
32 4B 31 4B 14 4B 17 4S
B
(∗6)
(∗6)
LG
LG
G
D7
Junction Connector
Hazard Warning
4 A 3 A 1 A 2 A Signal SW
A24(A), B13(B)
1
W–B
3 B 5 B
Turn Signal Lamp (Front Side RH)
Turn Signal Lamp (Front Side LH)
(∗6)
(∗6)
LG
LG
G
G
Turn Signal Lamp
B8(B), B24(C)
2 B (∗4) 2 B (∗4)
W–B
(Front RH)
1 1
(Front LH)
1 C (∗3) 1 C (∗3)
5
A2
A1
D40
1 B (∗4) 1 B (∗4) 2 2 Junction
2 C (∗3) 2 C (∗3) Connector
11
W–B
W–B
W–B
W–B
(∗6)
(∗6)
W–B
W–B
8
W–B W–B
BA1
3 5A 5 5A
W–B
W–B
B1 A1 D1
158
YARIS (EM02C4EL)
B
6 5
TR TL
E TR TL
∗ 1 : From Jan. 2008 Production until Oct. 2009 Production
Signal SW
∗ 2 : Before Jan. 2008 Production RH
Headlamp Dimmer SW
∗ 3 : From Jan. 2009 Production
Turn
∗ 4 : Before Jan. 2009 Production N
∗ 5 : Outer Rear View Mirror Type
∗ 6 : Front Fender Type LH
Assembly
∗ 7 : From Oct. 2009 Production
E
D4
7
W–B
28 4E
28 4A 27 4A 16 4S 13 4S 17 4E
BR(∗5)
(∗5)
(∗5)
BR
LG
LG
Y
LG(∗5)
(∗6)
(∗6)
BR
LG
Junction Connector
2 B 1 B 4 B 3 B
D34(A), D35(B)
15 F 8 F (∗7) 10 A 8 A
Rear Combination Lamp (RH)
15 D 8 D (∗1)
Rear Combination Lamp (LH)
15 B 8 B (∗2)
(∗5)
(∗5)
R
B
5 5
Turn RH
13 FD2 13 GD2
Turn LH
W–B
Turn
Turn
Combination Meter
(∗5)
(∗5)
D1(A), (C), (E),
J3
J4
G
D2(B), (D), (F)
4 4
View Mirror (RH)
10 10
View Mirror (LH)
TRNR TRNL
Outer Rear
Outer Rear
24 E (∗7)
24 C (∗1) GND GND
G9
F9
24 A (∗2) 6 6
W–B
W–B
W–B
W–B
(∗5)
(∗5)
BR
4 6B 4 5B
J1 J2 D3 D2 D1 D2
159
YARIS (EM02C4EL)
Turn Signal and Hazard Warning Light (LHD)
: Parts Location
Code See Page Code See Page Code See Page
A1 46 (LHD) C 52 (*2) 48 (*1)
D1 D34 A
A2 46 (LHD) E 52 (*2) 52 (*2)
A24 A 46 (LHD) B 48 (*1) 48 (*1)
D35 B
B1 B 46 (LHD) 48 (*1) 52 (*2)
D2 D
B8 B 46 (LHD) 52 (*2) 49 (*1)
D40
B13 B 46 (LHD) F 52 (*2) 53 (*2)
B18 C 46 (LHD) 48 (*1) F9 56 (LHD)
D4
B24 C 46 (LHD) 52 (*2) G9 56 (LHD)
A 48 (*1) 48 (*1) J3 57 (LHD)
D1 D7
C 48 (*1) 52 (*2) J4 57 (LHD)
: Relay Blocks
Code See Page Relay Blocks (Relay Block Location)
1 24 Engine Room R/B (Engine Compartment Left)
: Ground Points
Code See Page Ground Points Location
A1 70 (LHD) Left Suspension Tower
B1 70 (LHD) Radiator Support Left
72 (*1)
D1 Left Kick Panel
73 (*2)
72 (*1)
D2 Right Kick Panel
73 (*2)
72 (*1)
D3 Instrument Panel Reinforcement Left
73 (*2)
J1 74 (LHD) Right Rear Quarter Panel
J2 74 (LHD) Left Rear Quarter Panel
*1: LHD Before Jan. 2009 Production *2: LHD From Jan. 2009 Production *3: RHD Before Jan. 2009 Production
*4: RHD From Jan. 2009 Production
160
YARIS (EM02C4EL)
Memo
161
YARIS (EM02C4EL)
Turn Signal and Hazard Warning Light (RHD)
D71
1 Turn Signal Flasher
IG
B LR LL
4 2 3
LG
G
R
4 4R 2 4R 3 4R
32 4B 31 4B 14 4B 28 4A 27 4A 16 4S 13 4S
LG(∗7)
BR(∗7)
BR(∗7)
(∗8)
BR
LG(∗7)
(∗8)
(∗8)
(∗8)
LG
LG
LG
LG
G
Y
Junction Connector
4 A 3 A 1 A 2 A
A24(A), B13(B)
3 B 5 B
Turn Signal Lamp (Front Side RH)
Turn Signal Lamp (Front Side LH)
(∗8)
15 F 8 F (∗9)
LG
G
LG
G
15 D 8 D (∗3)
5 5 15 B 8 B (∗4)
B1(A), (B), B19(D)
1 A (∗1) 1 A (∗1)
2 B (∗2 ∗6) 2 B (∗2 ∗6)
Turn
Turn
(Front RH)
1 1
(Front LH)
2 D (∗5) 2 D (∗5)
Turn RH
Turn LH
J3
J4
4 4
A2
A1
2 A (∗1) 2 A (∗1)
Combination Meter
2 2
1 B (∗2 ∗6) 1 B (∗2 ∗6)
D1(A), (C), (E),
D2(B), (D), (F)
1 D (∗5) 1 D (∗5)
W–B
W–B
W–B
W–B
W–B
W–B
(∗8)
(∗8)
24 E (∗9)
8 24 C (∗3)
W–B W–B 24 A (∗4)
BA1
BR
W–B
W–B
B1 A1 J1 J2 D3
162
YARIS (EM02C4EL)
D4
Headlamp Dimmer SW
Assembly
E TR TL
Signal SW
RH
Turn
N
D71
Turn Signal Flasher
LH
E TR TL
11 13 12
HAZ E EL ER
8 7 5 6
W–B
W–B
B
B
8 4R 7 4R 5 4R 6 4R 28 4E 12 4S 11 4S
17 4S 17 4E
LG(∗7)
BR(∗7)
B
BR(∗7)
LG(∗7)
4
Junction Connector
D7
2 B 1 B 4 B 3 B
D34(A), D35(B)
Hazard Warning
Signal SW
10 A 8 A
W–B
(∗7)
(∗7)
R
B
13 FD2 13 GD2
W–B
W–B
(∗7)
(∗7)
G
5
D40
Junction
Connector
View Mirror (RH)
10 10
View Mirror (LH)
11
TRNR TRNL
Outer Rear
Outer Rear
GND GND
W–B
W–B
G9
F9
6 6
W–B
W–B
(∗7)
(∗7)
1 5A 5 5A
4 6B 4 5B
D2 D1 D1 D2
163
YARIS (EM02C4EL)
Turn Signal and Hazard Warning Light (RHD)
: Parts Location
Code See Page Code See Page Code See Page
A1 58 (RHD) C 64 (*4) 60 (*3)
D1 D35 B
A2 58 (RHD) E 64 (*4) 64 (*4)
A24 A 58 (RHD) B 60 (*3) 61 (*3)
D40
A 58 (RHD) 60 (*3) 65 (*4)
B1 D2 D
B 58 (RHD) 64 (*4) 61 (*3)
D71
A 58 (RHD) F 64 (*4) 65 (*4)
B8
B 58 (RHD) 60 (*3) F9 68 (RHD)
D4
B13 B 58 (RHD) 64 (*4) G9 68 (RHD)
B19 D 58 (RHD) 60 (*3) J3 69 (RHD)
D7
B25 D 58 (RHD) 64 (*4) J4 69 (RHD)
A 60 (*3) 60 (*3)
D1 D34 A
C 60 (*3) 64 (*4)
: Relay Blocks
Code See Page Relay Blocks (Relay Block Location)
1 24 Engine Room R/B (Engine Compartment Left)
: Ground Points
Code See Page Ground Points Location
A1 76 (RHD) Left Suspension Tower
B1 76 (RHD) Radiator Support Left
78 (*3)
D1 Left Kick Panel
79 (*4)
78 (*3)
D2 Right Kick Panel
79 (*4)
78 (*3)
D3 Instrument Panel Reinforcement Right
79 (*4)
J1 80 (RHD) Right Rear Quarter Panel
J2 80 (RHD) Left Rear Quarter Panel
*1: LHD Before Jan. 2009 Production *2: LHD From Jan. 2009 Production *3: RHD Before Jan. 2009 Production
*4: RHD From Jan. 2009 Production
164
YARIS (EM02C4EL)
Memo
165
YARIS (EM02C4EL)
K1
166
Map Lamp
1
2
L L L
5 4K
13 4B
(BAT)
2
W–B 15A
DOME
Interior Light
K2
Room Lamp (Center)
3
W–B
On
1
Off L
2
P
Door
2
1
GR GR L
10 A
1 B
4 4P
12 JD1
J12 D38(A), D39(B)
Room Lamp (Luggage) Junction
Connector
23
SB
6 B
7 4A
BCTY
O(∗6)
BE(∗5)
YARIS (EM02C4EL)
Main Body ECU
1
2
W
2 A
5 B
Courtesy
1
2
W–B BR BR
N1
12 MJ1
15 MN1
N2
Back Door
Lock Assembly
7
P
2 4K
ILE
1
W–B
1 4K
GND1
∗ 1 : w/o Smart Entry & Start System
∗ 2 : w/ Smart Entry & Start System
∗ 3 : From Jan. 2008 Production
∗ 4 : Before Jan. 2008 Production
∗ 5 : From Jan. 2009 Production
∗ 6 : Before Jan. 2009 Production
17 4E 15 4A 7 4D
(∗5)
(∗6)
BE
8 JD2
W–B
(∗1)
Y
BE
(∗5)
(∗6)
O
Unlock Warning SW
(RHD)
(RHD)
1 L L
L
(LHD)
(∗5)
(∗6)
(∗5)
(∗6)
L
BE
BE
O
O
D19
(LHD)
2
L
(∗5)
(∗6)
(∗5)
(∗6)
8 7
BE
BE
O
LSSR LSSR
6 6
Detection
Detection
Door Lock Assembly
W–B
Unlock
Unlock
(∗1)
LSSR LSSR
Detection
Detection
Unlock
Unlock
(Front RH)
(Rear RH)
(Front LH)
(Rear LH)
E E E E
G5
H3
F5
I3
9 9 7 8
W–B
W–B
12 HJ1 12 IJ1
W–B
W–B
W–B
W–B
W–B
1 6A (LHD)
3 6A (RHD)
1 5B 1 6B
D2 D1 D2
167
YARIS (EM02C4EL)
Interior Light
7. 5A 25A 7. 5A
ACC D/L ECU–B
1
16 25
L L L
AA2 AA2
(LHD)(RHD)
30 4B 2 4S
(∗1)
D33(A), (E), D64(B), (F), D65(C), D66(D)
21 4 Main Body ECU 6
ACC ALTB ECUB(∗1)
W–B
(∗2)
(∗2)
LG
21 4A 24 4A 20 4A 5 4A
11
SWIL
W
R
(RHD)
(RHD)
(LHD)
(LHD)
G
R
Junction Connector
Power SW
5 16
D55
D42
GND COM
Door Courtesy SW (Rear RH)
5 4 7 18
W–B
(∗2)
(∗2)
Door Courtesy SW
Door Courtesy SW
J33(A), (B)
(Front RH)
W
(Front LH)
J1(A), (B)
J2(A), (B)
W–B G
(∗2)
W–B
W–B
(∗2)
(∗2)
D1 D2
168
YARIS (EM02C4EL)
∗ 1 : w/o Smart Entry & Start System
(BAT) ∗ 2 : w/ Smart Entry & Start System
∗ 3 : From Jan. 2008 Production
∗ 4 : Before Jan. 2008 Production
15A ∗ 5 : From Jan. 2009 Production
AM2 ∗ 6 : Before Jan. 2009 Production
∗ 7 : Before Oct. 2009 Production
∗ 8 : From Oct. 2009 Production
2 ∗ 9 : From Jan. 2008 Production until Oct. 2009 Production
1 1B
2 E (∗8)
D1(A), (C), (E) 2 C (∗9)
Combination Meter 2 A (∗4)
(∗2)
D33(A), (E), D64(B), (F), D65(C), D66(D) GR
Main Body ECU
AM2 AM1
6 F (∗3) 1 C
6 B (∗4) Door
LED Driver
4 AD2
(∗2 ∗5)
(∗2 ∗6)
CPU
(∗2)
(∗2)
GR
SB
BE
CAN Controller
CAN I/F
7 A 6 A 21 E 20 E 24 E (∗8)
D36(A)
Junction 21 C 20 C 24 C (∗9)
Connector 21 A 20 A 24 A (∗4)
5 A
W
G
BR
D3
169
YARIS (EM02C4EL)
Interior Light
: Parts Location
Code See Page Code See Page Code See Page
48 (*1) 52 (*2) 57 (LHD)
A A
60 (*3) D39 B 60 (*3) 69 (RHD)
J2
48 (*1) 64 (*4) 57 (LHD)
B
52 (*2) 49 (*1) 69 (RHD)
D1 C
60 (*3) 53 (*2) 57 (LHD)
D42 J12
64 (*4) 61 (*3) 69 (RHD)
52 (*2) 65 (*4) 57 (LHD)
E J28 A
64 (*4) 61 (*3) 69 (RHD)
D55
48 (*1) 65 (*4) 57 (LHD)
J29 B
52 (*2) B 61 (*3) 69 (RHD)
D19 D64
60 (*3) F 61 (*3) 57 (LHD)
J30
64 (*4) 61 (*3) 69 (RHD)
D65 C
48 (*1) 65 (*4) 57 (LHD)
A A
60 (*3) 61 (*3) 69 (RHD)
D66 D J32
48 (*1) 65 (*4) 57 (LHD)
D33 B
52 (*2) 56 (LHD) 69 (RHD)
E F5
60 (*3) 68 (RHD) 57 (LHD)
A
64 (*4) 56 (LHD) 69 (RHD)
G5 J33
48 (*1) 68 (RHD) 57 (LHD)
B
52 (*2) 56 (LHD) 69 (RHD)
D36 A H3
60 (*3) 68 (RHD) 56 (LHD)
K1
64 (*4) 56 (LHD) 68 (RHD)
I3
48 (*1) 68 (RHD) 56 (LHD)
K2
52 (*2) 57 (LHD) 68 (RHD)
D38 A A
60 (*3) 69 (RHD) 56 (LHD)
J1 N2
64 (*4) 57 (LHD) 68 (RHD)
B
D39 B 48 (*1) 69 (RHD)
: Relay Blocks
Code See Page Relay Blocks (Relay Block Location)
1 24 Engine Room R/B (Engine Compartment Left)
*1: LHD Before Jan. 2009 Production *2: LHD From Jan. 2009 Production *3: RHD Before Jan. 2009 Production
*4: RHD From Jan. 2009 Production
170
YARIS (EM02C4EL)
: Connector Joining Wire Harness and Wire Harness
Code See Page Joining Wire Harness and Wire Harness (Connector Location)
72 (*1)
73 (*2)
AA2 Engine Room Main Wire and Engine Room Main Wire (Instrument Panel Left)
78 (*3)
79 (*4)
72 (*1)
73 (*2)
AD2 Engine Room Main Wire and Instrument Panel Wire (Instrument Panel Left)
78 (*3)
79 (*4)
72 (*1)
73 (*2)
FD1 Front Door RH Wire and Instrument Panel Wire (Right Kick Panel)
78 (*3)
79 (*4)
72 (*1)
73 (*2)
GD1 Front Door LH Wire and Instrument Panel Wire (Left Kick Panel)
78 (*3)
79 (*4)
74 (LHD)
HJ1 Rear Door No.1 Wire and Floor Wire (Right Center Pillar)
80 (RHD)
74 (LHD)
IJ1 Rear Door No.2 Wire and Floor Wire (Left Center Pillar)
80 (RHD)
72 (*1)
73 (*2)
JD1
78 (*3)
79 (*4)
Floor Wire and Instrument Panel Wire (Instrument Panel Left)
72 (*1)
73 (*2)
JD2
78 (*3)
79 (*4)
74 (LHD)
MJ1 Back Door No.1 Wire and Floor Wire (Left Rear Quarter Panel)
80 (RHD)
74 (LHD)
MN1 Back Door No.1 Wire and Back Door No.2 Wire (Back Door Panel Center)
80 (RHD)
: Ground Points
Code See Page Ground Points Location
72 (*1)
73 (*2)
D1 Left Kick Panel
78 (*3)
79 (*4)
72 (*1)
73 (*2)
D2 Right Kick Panel
78 (*3)
79 (*4)
72 (*1)
Instrument Panel Reinforcement Left
73 (*2)
D3
78 (*3)
Instrument Panel Reinforcement Right
79 (*4)
74 (LHD)
N1 Back Door Panel Center
80 (RHD)
*1: LHD Before Jan. 2009 Production *2: LHD From Jan. 2009 Production *3: RHD Before Jan. 2009 Production
*4: RHD From Jan. 2009 Production
171
YARIS (EM02C4EL)
1
D4(A), (B) B
172
Headlamp Dimmer SW Assembly
(BAT)
120A ALT
A28
Fusible
SW
Link Block
Light
Control
W–B
4 5A
D1
(∗1 LHD)
1 4G
Tail
OFF
Head
B1
W (∗2)
B1
4 4M
(∗2)
T1
W–B
T1
4 6A
D2
13 A (LHD)
5 B (RHD)
(∗1 RHD)
10A
TAIL
(∗2)
10 A (LHD)
8 B (RHD)
W (∗1) (∗1)
9 4S
Taillight and Illumination
G
(∗1)
(∗2)
(∗1)
G
(∗2) 10 4E T–LP Relay
(∗1)
Clearance
2
4
W–B G
HI
(HID Type) (HID Type)
B16
Headlamp Assembly (RH)
7 B
B1
YARIS (EM02C4EL)
(Except HID Type) (Except HID Type)
1 A (∗9)
2 A (∗9)
2 B (LHD ∗8)
1 B (LHD ∗8)
1 C (RHD ∗8)
2 C (RHD ∗8)
B7(A), B20(B), B21(C)
Clearance Lamp (LH)
W–B G P
8 B
12 A
33 4B
1 A (∗9)
2 A (∗9)
A24(A), B13(B)
Junction
(∗2)
10A
2 B (LHD ∗8)
1 B (LHD ∗8)
Connector
1 C (RHD ∗8)
2 C (RHD ∗8)
7. 5A
PANEL2
TAIL (∗1)
Clearance
2
4
W–B G
B
HI
(HID Type) (HID Type)
B17
Headlamp Assembly (LH)
Y
8 4P 10 4P
7. 5A
PANEL1
10 4A 29 4A 7 4P 2 4Q
R
R
GR
G(∗9)
G(∗8)
G
16 F 14 E (∗11)
G
16 D 14 C (∗6)
16 B 14 A (∗7)
Rear Combination Lamp (RH)
1 1
2
Tail
Tail
J38
Combination Meter
1 CPU
J3
J4
4 4
24 E (∗11)
24 C (∗6)
24 A (∗7)
W–B
W–B
W–B
173
YARIS (EM02C4EL)
Taillight and Illumination
Y Y
V V
5
G(∗9) G
DE1
(∗9)
G(∗8)
R
20 A (∗9) E10(A), D88(B)
20 B (∗8) Junction Connector 3
19 A 21 A 22 A (∗9)
B
L
2 A (∗9) 5 A (∗3)
5 B (∗4)
E6(A), (B), (C), D98(D)
2 B (∗8)
D7
ILL+ 5 C (∗10) 5 A (∗9) 2
5 D (∗8) 5 B (∗8)
E1(A), D93(B)
E5(A), D97(B)
W
Blower SW
A/C SW
E W
5 A (∗9) 4 A (∗3) 6 A (∗9)
5 B (∗8) 4 B (∗4) 6 B (∗8)
4 C (∗10)
4 D (∗8)
(RHD ∗9)
(LHD ∗9)
W–B
W–B
W–B
(∗8)
(∗8)
(∗9)
W
10 A 8 A (∗9)
10 B 8 B (∗8)
R
(∗9)
(RHD ∗9)
(RHD ∗8)
(LHD ∗9)
(LHD ∗8)
W–B
W–B
W–B
W–B
D1 D2 D1
174
YARIS (EM02C4EL)
V
Y
W
W–B
D2
20 B
Junction
Connector
D36(A), D37(B)
D20
A/T Shift Lever Illumination
1
2
W–B W–B W G
15 A
19 B
D1
(A/T) (A/T)
(∗5)
W–B
5
GND
W–B
(∗5)
4
COM
11
W–B LG G
3 A
8 B
8 C
13 C
TLH
SWIL
(∗5) (∗5) (∗5)
SWIL
D55
D65(C)
Power SW
YARIS (EM02C4EL)
7
10
W–B G V
2 A
9 B
D3
ILL+
GND
D38(A), D39(B)
D10 Junction Connector
Radio Receiver Assembly
4
3
B1
9 BA1
10 AA2
7 AD3
D52
Headlamp Leveling SW
175
Taillight and Illumination
: Parts Location
Code See Page Code See Page Code See Page
46 (LHD) 48 (*1) D52 61 (*3)
A24 A A
58 (RHD) 52 (*2) 61 (*3)
D4 D55
42, 46 (LHD) 60 (*3) 65 (*4)
A28 B
42, 58 (RHD) 64 (*4) 61 (*3)
D65 C
46 (LHD) 48 (*1) 65 (*4)
B3 A
58 (RHD) 52 (*2) 53 (*2)
D7 D88 B
46 (LHD) 60 (*3) 65 (*4)
B7 A
58 (RHD) 64 (*4) 53 (*2)
D93 B
46 (LHD) 48 (*1) 65 (*4)
B13 B
58 (RHD) 52 (*2) 53 (*2)
D10 D97 B
B16 58 (RHD) 60 (*3) 65 (*4)
B17 58 (RHD) 64 (*4) 53 (*2)
D98 D
B20 B 46 (LHD) 48 (*1) 65 (*4)
B21 C 58 (RHD) 52 (*2) 50 (*1)
D20 E1 A
B22 B 46 (LHD) 60 (*3) 62 (*3)
B23 C 58 (RHD) 64 (*4) 50 (*1)
E5 A
48 (*1) 48 (*1) 62 (*3)
A
60 (*3) 52 (*2) 50 (*1)
D36 A A
48 (*1) 60 (*3) 62 (*3)
52 (*2) 64 (*4) 50 (*1)
D1 C E6 B
60 (*3) 48 (*1) 62 (*3)
64 (*4) 52 (*2) 50 (*1)
D37 B C
52 (*2) 60 (*3) 62 (*3)
E
64 (*4) 64 (*4) 50 (*1)
E10 A
48 (*1) 48 (*1) 62 (*3)
B
60 (*3) 52 (*2) 57 (LHD)
D38 A J3
48 (*1) 60 (*3) 69 (RHD)
52 (*2) 64 (*4) 57 (LHD)
D2 D J4
60 (*3) 48 (*1) 69 (RHD)
64 (*4) 52 (*2) 57 (LHD)
D39 B J38
52 (*2) 60 (*3) 69 (RHD)
F
64 (*4) 64 (*4)
*1: LHD Before Jan. 2009 Production *2: LHD From Jan. 2009 Production *3: RHD Before Jan. 2009 Production
*4: RHD From Jan. 2009 Production
176
YARIS (EM02C4EL)
: Connector Joining Wire Harness and Wire Harness
Code See Page Joining Wire Harness and Wire Harness (Connector Location)
72 (*1)
73 (*2)
AA2 Engine Room Main Wire and Engine Room Main Wire (Instrument Panel Left)
78 (*3)
79 (*4)
72 (*1)
73 (*2)
AD3 Engine Room Main Wire and Instrument Panel Wire (Instrument Panel Left)
78 (*3)
79 (*4)
70 (LHD)
BA1 Engine Room No.2 Wire and Engine Room Main Wire (Engine Compartment Left)
76 (RHD)
72 (*1)
DE1
78 (*3) Instrument Panel Wire and Instrument Panel No.2 Wire (Instrument Panel Left)
DE2 78 (*3)
ED1 72 (*1) Instrument Panel No.2 Wire and Instrument Panel Wire (Instrument Panel Left)
: Ground Points
Code See Page Ground Points Location
70 (LHD)
B1 Radiator Support Left
76 (RHD)
72 (*1)
73 (*2)
D1 Left Kick Panel
78 (*3)
79 (*4)
72 (*1)
73 (*2)
D2 Right Kick Panel
78 (*3)
79 (*4)
72 (*1)
Instrument Panel Reinforcement Left
73 (*2)
D3
78 (*3)
Instrument Panel Reinforcement Right
79 (*4)
74 (LHD)
J1 Right Rear Quarter Panel
80 (RHD)
74 (LHD)
J2 Left Rear Quarter Panel
80 (RHD)
*1: LHD Before Jan. 2009 Production *2: LHD From Jan. 2009 Production *3: RHD Before Jan. 2009 Production
*4: RHD From Jan. 2009 Production
177
YARIS (EM02C4EL)
Back-Up Light
(IG)
10A
GAUGE
19 4B
1 CA1
(M/T)
(A/T)
G
J28(A), J29(B)
9 B Junction Connector
2 2
C22 RB RL C27
Back–Up Lamp SW Park/Neutral
Position SW
R
10 A 9 A
1 1
(M/T)
(A/T)
BR
R
Back–Up
3 CA1
J3
J4
4 4
R
30 4A
22 4B
W–B
W–B
J1 J2
178
YARIS (EM02C4EL)
: Parts Location
Code See Page Code See Page Code See Page
47 (LHD) 57 (LHD) 57 (LHD)
C22 J3 J28 A
59 (RHD) 69 (RHD) 69 (RHD)
47 (LHD) 57 (LHD) 57 (LHD)
C27 J4 J29 B
59 (RHD) 69 (RHD) 69 (RHD)
: Ground Points
Code See Page Ground Points Location
74 (LHD)
J1 Right Rear Quarter Panel
80 (RHD)
74 (LHD)
J2 Left Rear Quarter Panel
80 (RHD)
179
YARIS (EM02C4EL)
Stop Light
(BAT)
∗ 1 : From Jan. 2009 Production
∗ 2 : Before Jan. 2009 Production
10A ∗ 3 : LED Type
STOP ∗ 4 : Bulb Type
18 4B
B
2 BE
A13
Stop Lamp SW (∗1)
O
(∗2)
1
G
12 4B 10 MJ1
12 4A
(∗1)
(∗2)
BE
O
V
J28(A), J29(B)
3 B Junction Connector 4 B
3 A 4 A
M1
2
(∗1)
(∗2)
BE
O
V
2 2
Rear Combination Lamp (RH)
Rear Combination Lamp (LH)
W–B
(∗3)
(∗4)
(∗3)
(∗4)
Stop
Stop
Stop
Stop
(∗3)
(∗4)
(∗3)
(∗4)
11 MJ1
J4
J3
4 4
W–B
W–B
W–B
7
W–B W–B
MJ1
B
W–B
8 MN1
W–B
W–B
N1 J2 J1
180
YARIS (EM02C4EL)
: Parts Location
Code See Page Code See Page Code See Page
50 (*1) J3 69 (RHD) 57 (LHD)
J29 B
54 (*2) 57 (LHD) 69 (RHD)
A13 J4
62 (*3) 69 (RHD) 56 (LHD)
M1
66 (*4) 57 (LHD) 68 (RHD)
J28 A
J3 57 (LHD) 69 (RHD)
: Ground Points
Code See Page Ground Points Location
74 (LHD)
J1 Right Rear Quarter Panel
80 (RHD)
74 (LHD)
J2 Left Rear Quarter Panel
80 (RHD)
74 (LHD)
N1 Back Door Panel Center
80 (RHD)
*1: LHD Before Jan. 2009 Production *2: LHD From Jan. 2009 Production *3: RHD Before Jan. 2009 Production
*4: RHD From Jan. 2009 Production
181
YARIS (EM02C4EL)
Front Fog Light
(BAT)
(∗1)
(∗1)
(∗1)
(∗2)
B
10A 7. 5A
TAIL T–LP PANEL2
Relay
(∗2)
(∗1)
(∗2)
(∗1)
1 4G 4 4M (∗2) 9 4S 10 4E
(∗1)
(∗2)
W
G
13 A (LHD) D4(A), (B)
5 B (RHD) Headlamp Dimmer SW Assembly
B1
B1 T1 LFG BFG
Head Rear(∗3)
T1 LFG BFG
10 A 4 A 3 A (LHD)
8 B 1 B 2 B (RHD)
Y
(∗1 LHD)
(∗1 RHD)
W–B
W–B
W–B
(∗2)
G
5
D40
Junction
Connector
11
W–B
4 5A 4 6A 3 5A (LHD)
1 5A (RHD)
D1 D2 D1
182
YARIS (EM02C4EL)
(BAT) ∗ 1 : w/ Theft Deterrent System
∗ 2 : w/o Theft Deterrent System
∗ 3 : w/ Rear Fog Light
15A ∗ 4 : From Jan. 2008 Production until Oct. 2009 Production
FR FOG ∗ 5 : Before Jan. 2008 Production
∗ 6 : From Oct. 2009 Production
9 4M
7. 5A
PANEL1
7 4Q
V
2 5
D46
Front Fog
Light Relay
1 3
R
7 AD2
R
A24(A), B13(B)
6 A Junction Connector
2 B 1 B
7 F (∗6)
7 D (∗4)
D1(A), (C), (E), D2(B), (D), (F)
7 B (∗5)
R
2 2
1 1
B10
B9
24 E (∗6)
24 C (∗4)
24 A (∗5)
W–B
W–B
W–B
BR
D3 B1
183
YARIS (EM02C4EL)
Front Fog Light
: Parts Location
Code See Page Code See Page Code See Page
46 (LHD) 52 (*2) 48 (*1)
A24 A A
58 (RHD) C 60 (*3) 52 (*2)
D4
42, 46 (LHD) D1 64 (*4) 60 (*3)
A28 B
42, 58 (RHD) 52 (*2) 64 (*4)
E
46 (LHD) 64 (*4) 49 (*1)
B9
58 (RHD) 48 (*1) 53 (*2)
B D40
46 (LHD) 60 (*3) 61 (*3)
B10
58 (RHD) 48 (*1) 65 (*4)
46 (LHD) 52 (*2) 49 (*1)
B13 B D2 D
58 (RHD) 60 (*3) 53 (*2)
D46
48 (*1) 64 (*4) 61 (*3)
A
D1 60 (*3) 52 (*2) 65 (*4)
F
C 48 (*1) 64 (*4)
: Ground Points
Code See Page Ground Points Location
70 (LHD)
B1 Radiator Support Left
76 (RHD)
72 (*1)
73 (*2)
D1 Left Kick Panel
78 (*3)
79 (*4)
78 (*3)
D2 Right Kick Panel
79 (*4)
72 (*1)
Instrument Panel Reinforcement Left
73 (*2)
D3
78 (*3)
Instrument Panel Reinforcement Right
79 (*4)
*1: LHD Before Jan. 2009 Production *2: LHD From Jan. 2009 Production *3: RHD Before Jan. 2009 Production
*4: RHD From Jan. 2009 Production
184
YARIS (EM02C4EL)
Memo
185
YARIS (EM02C4EL)
Rear Fog Light
(BAT)
1
(∗2) (∗1)
(∗1)
(∗1)
(∗2)
B
T–LP
10A Relay 7. 5A 7. 5A
TAIL PANEL2 PANEL1
(∗2)
(∗1)
(∗2)
1 4G 4 4M 9 4S 10 4E 7 4Q 2 4Q
(∗2)
(∗1)
(∗2)
(∗3)
W
R
V
R
V
(∗3)
13 A 10 A (LHD)
5 B 8 B (RHD)
B1 T1
B1 T1
Light OFF
(∗2)
Control
SW Tail
Head
(∗1)
T1
10 A (LHD) D4(A), (B)
8 B (RHD) Headlamp Dimmer SW
Assembly
(∗1 RHD)
(∗1 LHD)
W–B
W–B
4 6A 4 5A
D2 D1
186
YARIS (EM02C4EL)
(BAT) (BAT) ∗ 1
: w/ Theft Deterrent System
∗ 2
: w/o Theft Deterrent System
∗ 3
: w/ Front Fog Light
15A 7. 5A ∗ 5
: From Jan. 2008 Production
FR FOG RR FOG until Oct. 2009 Production
∗ 6 : Before Jan. 2008 Production
∗ 7 : From Oct. 2009 Production
9 4M 2 4M
(∗3)
(∗3)
R
V
2 5 2 5
D46 D72
Front Fog Light Rear Fog Light
Relay Relay
R
1 3 1 3
V SB
(∗3)
(∗3)
(∗3)
R
R
Y
18 JD2
3 A 2 A (LHD)
2 B 3 B (RHD)
BFG B (RHD)
(LHD)
SB
SB
SB
BFG LFG B
Fog Light SW
OFF 6 F (∗7)
D1(A), (C), (E), D2(B), (D), (F)
6 D (∗5)
Front(∗3) 6 6
6 B (∗6)
Rear
Rear Combination
Rear Combination
Combination Meter
Rear Fog
Rear Fog
Lamp (RH)
Lamp (LH)
Rear Fog
LFG
J3
(RHD)
(LHD)
W–B
W–B
BR
5
D40
Junction
Connector
11
W–B
3 5A (LHD)
1 5A (RHD)
D1 D3 J1 J2
187
YARIS (EM02C4EL)
Rear Fog Light
: Parts Location
Code See Page Code See Page Code See Page
42, 46 (LHD) 48 (*1) 61 (*3)
A28 D40
42, 58 (RHD) 52 (*2) 65 (*4)
D
48 (*1) 60 (*3) 49 (*1)
A D2
60 (*3) 64 (*4) 53 (*2)
D46
48 (*1) 52 (*2) 61 (*3)
F
52 (*2) 64 (*4) 65 (*4)
D1 C
60 (*3) 48 (*1) 49 (*1)
A
64 (*4) 52 (*2) 53 (*2)
D4 D72
52 (*2) 60 (*3) 61 (*3)
E B
64 (*4) 64 (*4) 65 (*4)
48 (*1) 49 (*1) J3 69 (RHD)
D2 B D40
60 (*3) 53 (*2) J4 57 (LHD)
: Ground Points
Code See Page Ground Points Location
72 (*1)
73 (*2)
D1 Left Kick Panel
78 (*3)
79 (*4)
72 (*1)
73 (*2)
D2 Right Kick Panel
78 (*3)
79 (*4)
72 (*1)
Instrument Panel Reinforcement Left
73 (*2)
D3
78 (*3)
Instrument Panel Reinforcement Right
79 (*4)
74 (LHD)
J1 Right Rear Quarter Panel
80 (RHD)
74 (LHD)
J2 Left Rear Quarter Panel
80 (RHD)
*1: LHD Before Jan. 2009 Production *2: LHD From Jan. 2009 Production *3: RHD Before Jan. 2009 Production
*4: RHD From Jan. 2009 Production
188
YARIS (EM02C4EL)
Memo
189
YARIS (EM02C4EL)
Horn
10A
HORN
HORN
Relay
7 1A 8 1A
LG
G
28 4B 17 AA2
18 4E
G
1 BA1
G
B
8 C (∗1)
8 A (∗2)
HO D3(A), (C), V2(B)
Spiral Cable
1 B
R
1
B2
V2(B) Horn
Horn SW
190
YARIS (EM02C4EL)
: Parts Location
Code See Page Code See Page Code See Page
46 (LHD) 48 (*1) 51 (*1)
B2
58 (RHD) 52 (*2) 55 (*2)
D3 C V2 B
48 (*1) 60 (*3) 63 (*3)
D3 A
60 (*3) 64 (*4) 67 (*4)
*1: LHD Before Jan. 2009 Production *2: LHD From Jan. 2009 Production *3: RHD Before Jan. 2009 Production
*4: RHD From Jan. 2009 Production
191
YARIS (EM02C4EL)
Key Reminder (w/o Smart Entry & Start System)
1 4M 1
L
16 AA2 (LHD)
25 AA2 (RHD)
B
L
L
2 4S 30 4B
1 E 2 E (∗4)
1 C 2 C (∗1) D33(A), (E)
1 A 2 A (∗2) 6 Main Body ECU
ECUB
CPU
Y
CAN Controller
Unlock Warning SW
1
D19
Buzzer
2
W–B
20 C 21 C
R
R
Door Courtesy SW (Front RH)
Door Courtesy SW (Front LH)
20 A 21 A 24 A (∗2)
BR
1 A (∗3) 1 A (∗3)
1 B (∗4) 1 B (∗4)
W 18 16 W
J2(A), (B)
J1(A), (B)
G 7 5 R
D42
Junction 1 6A (LHD)
Connector 3 6A (RHD)
D3 D2
192
YARIS (EM02C4EL)
: Parts Location
Code See Page Code See Page Code See Page
48 (*1) 60 (*3) 61 (*3)
A D19 D42
60 (*3) 64 (*4) 65 (*4)
48 (*1) 48 (*1) 57 (LHD)
A A
52 (*2) 60 (*3) 69 (RHD)
D1 C J1
60 (*3) 48 (*1) 57 (LHD)
D33 B
64 (*4) 52 (*2) 69 (RHD)
E
52 (*2) 60 (*3) 57 (LHD)
E A
64 (*4) 64 (*4) 69 (RHD)
J2
48 (*1) 49 (*1) 57 (LHD)
D19 D42 B
52 (*2) 53 (*2) 69 (RHD)
: Relay Blocks
Code See Page Relay Blocks (Relay Block Location)
1 24 Engine Room R/B (Engine Compartment Left)
: Ground Points
Code See Page Ground Points Location
72 (*1)
73 (*2)
D2 Right Kick Panel
78 (*3)
79 (*4)
72 (*1)
Instrument Panel Reinforcement Left
73 (*2)
D3
78 (*3)
Instrument Panel Reinforcement Right
79 (*4)
*1: LHD Before Jan. 2009 Production *2: LHD From Jan. 2009 Production *3: RHD Before Jan. 2009 Production
*4: RHD From Jan. 2009 Production
193
YARIS (EM02C4EL)
Light Reminder
(BAT) (IG)
120A ALT
A28 7. 5A
Fusible MET
Link (∗2)
Block
(∗1)
(∗1)
(∗2)
1
T–LP Relay
1 4M
10A 7. 5A 7. 5A
TAIL PANEL2 PANEL1
B
(∗2)
(∗1)
(∗1)
(∗2)
1 4G 4 4M 9 4S 10 4E 2 4Q
(∗2)
(∗1)
(∗2)
W
B
L
13 A (LHD)
5 B (RHD)
G
B1
14 E 1 E 2 E (∗10)
B1 T1
14 C 1 C 2 C (∗11)
14 A 1 A 2 A (∗6)
Light OFF
Control
SW Tail
Head
Illumination I/F
T1 5V IC
(∗1 RHD)
W–B
W–B
Buzzer
4 5A 4 6A
D1 D2 D3
194
YARIS (EM02C4EL)
(BAT) (BAT) (ACC) (IG) (BAT)
ECU–IG
ECU–B
7. 5A
15A
ACC
25A
7. 5A
D/L
10A
AM2
2 2
1 1 1B
(∗3)
GR
L
4 AD2
16 AA2 (LHD)
(∗3)
GR
25 AA2 (RHD)
D36(A)
Junction
5 A Connector
L
L
6 A 7 A
2 4S 30 4B
(∗3 ∗7)
(∗3 ∗8)
(∗3)
BE
SB
O
(∗4)
6 F (∗5)
6 4 21 5 1 C 6 B (∗6)
ECUB(∗4) ALTB ACC IG AM1 AM2
16 5
Connector
Junction
D42
18 7
(RHD)
(LHD)
W–B
W
R
Door Courtesy SW (Front RH)
J2(A), (B)
D2
195
YARIS (EM02C4EL)
Light Reminder
: Parts Location
Code See Page Code See Page Code See Page
42, 46 (LHD) A 60 (*3) 61 (*3)
A28 D64 F
42, 58 (RHD) 48 (*1) 65 (*4)
48 (*1) D33 52 (*2) 61 (*3)
A E D65 C
60 (*3) 60 (*3) 65 (*4)
48 (*1) 64 (*4) 61 (*3)
D66 D
52 (*2) 48 (*1) 65 (*4)
D1 C
60 (*3) 52 (*2) 57 (LHD)
D36 A A
64 (*4) 60 (*3) 69 (RHD)
J1
52 (*2) 64 (*4) 57 (LHD)
E B
64 (*4) 49 (*1) 69 (RHD)
48 (*1) 53 (*2) 57 (LHD)
A D42 A
52 (*2) 61 (*3) 69 (RHD)
D4 J2
60 (*3) 65 (*4) 57 (LHD)
B B
64 (*4) 61 (*3) 69 (RHD)
D64 B
D33 A 48 (*1) 65 (*4)
: Relay Blocks
Code See Page Relay Blocks (Relay Block Location)
1 24 Engine Room R/B (Engine Compartment Left)
*1: LHD Before Jan. 2009 Production *2: LHD From Jan. 2009 Production *3: RHD Before Jan. 2009 Production
*4: RHD From Jan. 2009 Production
196
YARIS (EM02C4EL)
: Ground Points
Code See Page Ground Points Location
72 (*1)
73 (*2)
D1 Left Kick Panel
78 (*3)
79 (*4)
72 (*1)
73 (*2)
D2 Right Kick Panel
78 (*3)
79 (*4)
72 (*1)
Instrument Panel Reinforcement Left
73 (*2)
D3
78 (*3)
Instrument Panel Reinforcement Right
79 (*4)
*1: LHD Before Jan. 2009 Production *2: LHD From Jan. 2009 Production *3: RHD Before Jan. 2009 Production
*4: RHD From Jan. 2009 Production
197
YARIS (EM02C4EL)
ABS (Before Oct. 2009 Production)
(IG)
∗ 1 : w/ Smart Entry & Start System
∗ 2 : w/o Smart Entry & Start System
7. 5A ∗ 3 : From Jan. 2008 Production
MET ∗ 4 : Before Jan. 2008 Production
∗ 5 : From Jan. 2009 Production
∗ 6 : Before Jan. 2009 Production
1 4M
B
D1(A), (C) 1 C (∗3)
Combination Meter 1 A (∗4)
Brake
ABS
CPU
CAN Controller
CAN I/F
24 C 20 C 21 C (∗3)
24 A 20 A 21 A (∗4)
2 4C
W
R
D42
5 16 Junction Connector 7 18
Y
3 14 11 22
Parking Brake SW
1
(RHD)
(RHD)
W
V
V
D21
(LHD)
W
(LHD)
6 14 W
CANH CANL
Y
D3 D15
DLC3
198
YARIS (EM02C4EL)
(IG)
10A
GAUGE
19 4B
(A/T)
G
1 CA1
(A/T)
G
PL RB NL
C27
P Park/Neutral
Position SW
N
6 9
(A/T)
(A/T)
SB
R
A15
73 B 54 B Skid Control ECU with Actuator
P N
A21(A), C20(B)
Engine ECU
G
(Shielded)
P
L
G
W
L
Crankshaft Position
1
Junction Connector
15 4 12 1
Sensor
C2
D41
2
14 3 22 11
V
(LHD)
W
(LHD)
BR
W W
Y Y
C1
199
YARIS (EM02C4EL)
ABS (Before Oct. 2009 Production)
18 4B 24 4B 1 1
B
(RHD ∗6)
(RHD ∗6)
2 4 A (RHD)
Stop Lamp SW
B
16 B (LHD)
A25(A), A37(B)
Junction Connector
A13
7 A (RHD)
B
(Front LH) (Front RH) 8 AA1 7 AA1
G
2 1 2 1
(RHD ∗6)
12 4B
B
(RHD ∗6)
(RHD ∗6)
1 AA1
W
G
R
B
B
21 4B
(RHD ∗6)
B
G
10 25 9 8 31 30 1 23
STP IG1 FL+ FL– FR+ FR– +BS +BM
A15
Skid Control ECU with Actuator
W–B
LG
B
BR
W
1 2 1 2
a1 Z1
Speed Sensor (Rear LH) Speed Sensor (Rear RH)
A2
200
YARIS (EM02C4EL)
: Parts Location
Code See Page Code See Page Code See Page
46 (LHD) 47 (LHD) 52 (*2)
A7 C27
58 (RHD) 59 (RHD) D33 E 60 (*3)
46 (LHD) 48 (*1) 64 (*4)
A11 A
58 (RHD) 60 (*3) 49 (*1)
50 (*1) 48 (*1) 53 (*2)
D1 D41
54 (*2) 52 (*2) 61 (*3)
A13 C
62 (*3) 60 (*3) 65 (*4)
66 (*4) 64 (*4) 49 (*1)
46 (LHD) 48 (*1) 53 (*2)
A15 D42
58 (RHD) 52 (*2) 61 (*3)
D15
46 (LHD) 60 (*3) 65 (*4)
A21 A
58 (RHD) 64 (*4) 61 (*3)
D66 D
A25 A 58 (RHD) 48 (*1) 65 (*4)
46 (LHD) 52 (*2) 56 (LHD)
A37 B D21 Z1
58 (RHD) 60 (*3) 68 (RHD)
47 (LHD) 64 (*4) 56 (LHD)
C2 a1
59 (RHD) 48 (*1) 68 (RHD)
A
47 (LHD) D33 60 (*3)
C20 B
59 (RHD) E 48 (*1)
: Relay Blocks
Code See Page Relay Blocks (Relay Block Location)
1 24 Engine Room R/B (Engine Compartment Left)
*1: LHD Before Jan. 2009 Production *2: LHD From Jan. 2009 Production *3: RHD Before Jan. 2009 Production
*4: RHD From Jan. 2009 Production
201
YARIS (EM02C4EL)
ABS (Before Oct. 2009 Production)
: Ground Points
Code See Page Ground Points Location
70 (LHD)
A2 Left Suspension Tower
76 (RHD)
70 (LHD)
C1 Engine Block Left
76 (RHD)
72 (*1)
Instrument Panel Reinforcement Left
73 (*2)
D3
78 (*3)
Instrument Panel Reinforcement Right
79 (*4)
*1: LHD Before Jan. 2009 Production *2: LHD From Jan. 2009 Production *3: RHD Before Jan. 2009 Production
*4: RHD From Jan. 2009 Production
202
YARIS (EM02C4EL)
Memo
203
YARIS (EM02C4EL)
ABS (From Oct. 2009 Production)
(IG)
∗ 1 : w/ Smart Entry & Start System
∗ 2 : w/o Smart Entry & Start System
7. 5A
MET
1 4M
B
D1(E)
Combination Meter 1 E
Brake
ABS
CPU
CAN Controller
CAN I/F
24 E 20 E 21 E
D33(E), D66(D)
Main Body ECU W
G
2 4C
W
R
D42
5 16 Junction Connector 7 18
Y
3 14 11 22
Parking Brake SW
1
(RHD)
(RHD)
W
V
V
D21
(LHD)
W
(LHD)
6 14 W
CANH CANL
Y
D3 D15
DLC3
204
YARIS (EM02C4EL)
(IG)
10A
GAUGE
19 4B
(A/T)
G
1 CA1
(A/T)
G
PL RB NL
C27
P Park/Neutral
Position SW
N
6 9
(A/T)
(A/T)
SB
R
A38
73 B 54 B Skid Control ECU with Actuator
P N
A21(A), C20(B)
Engine ECU
G
(Shielded)
P
L
G
W
L
Crankshaft Position
1
Junction Connector
15 4 12 1
Sensor
C2
D41
2
14 3 22 11
V
(LHD)
W
(LHD)
BR
W W
Y Y
C1
205
YARIS (EM02C4EL)
ABS (From Oct. 2009 Production)
2 2
18 4B 24 4B 1 1
B
2 4 A (RHD)
Stop Lamp SW
16 B (LHD)
A25(A), A37(B)
Junction Connector
A13
7 A (RHD)
1 19 B (LHD) A11 A7
Speed Sensor Speed Sensor
B
(Front LH) (Front RH)
G
2 1 2 1
12 4B
G
R
B
V
21 4B
G
28 34 19 18 7 6 12 24
STP IG1 FL+ FL– FR+ FR– +BS +BM
A38
Skid Control ECU with Actuator
W–B
LG
B
BR
W
1 2 1 2
a1 Z1
Speed Sensor (Rear LH) Speed Sensor (Rear RH)
A2
206
YARIS (EM02C4EL)
: Parts Location
Code See Page Code See Page Code See Page
46 (LHD) 47 (LHD) 52 (*2)
A7 C2 D33 E
58 (RHD) 59 (RHD) 64 (*4)
46 (LHD) 47 (LHD) 53 (*2)
A11 C20 B D41
58 (RHD) 59 (RHD) 65 (*4)
54 (*2) 47 (LHD) 53 (*2)
A13 C27 D42
66 (*4) 59 (RHD) 65 (*4)
46 (LHD) 52 (*2) D66 D 65 (*4)
A21 A D1 E
58 (RHD) 64 (*4) 56 (LHD)
Z1
A25 A 58 (RHD) 52 (*2) 68 (RHD)
D15
A37 B 46 (LHD) 64 (*4) 56 (LHD)
a1
46 (LHD) 52 (*2) 68 (RHD)
A38 D21
58 (RHD) 64 (*4)
: Relay Blocks
Code See Page Relay Blocks (Relay Block Location)
1 24 Engine Room R/B (Engine Compartment Left)
: Ground Points
Code See Page Ground Points Location
70 (LHD)
A2 Left Suspension Tower
76 (RHD)
70 (LHD)
C1 Engine Block Left
76 (RHD)
73 (*2) Instrument Panel Reinforcement Left
D3
79 (*4) Instrument Panel Reinforcement Right
*1: LHD Before Jan. 2009 Production *2: LHD From Jan. 2009 Production *3: RHD Before Jan. 2009 Production
*4: RHD From Jan. 2009 Production
207
YARIS (EM02C4EL)
Memo
208
YARIS (EM02C4EL)
SRS
NOTICE : When inspecting or repairing the SRS, perform service in accordance with the following precautionary instructions
and the procedure, and precautions in the Repair Manual applicable for the model year.
● Malfunction symptoms of the SRS are difficult to confirm, so the DTCs become the most important source of information
when troubleshooting. When troubleshooting the SRS, always inspect the DTCs before disconnecting the battery.
● Work must be started more than 90 seconds after the ignition SW is turned to the ”LOCK” position (Ignition SW
type) or the power SW is pushed to the ”OFF” position (Power SW type) and the negative (-) terminal cable is
disconnected from the battery.
(The SRS is equipped with a back-up power source so that if work is started within 90 seconds from disconnecting
the negative (-) terminal cable of the battery, the SRS may deploy.)
● When the negative (-) terminal cable is disconnected from the battery, the memory of the clock and audio system will be
cleared. So before starting work, make a record of the contents in the audio memory system. When work is finished, reset
the audio systems as they were before and adjust the clock. Some vehicles have power tilt steering, power telescopic
steering, power seat and power outside rear view mirror which are all equipped with memory function. However, it is not
possible to make a record of these memory contents. So when the work is finished, it will be necessary to explain it to your
customer, and ask the customer to adjust the features and reset the memory. To avoid erasing the memory in each system,
never use a back-up power supply from outside the vehicle.
● Before repair, remove the airbag sensor if shocks are likely to be applied to the sensor during repair.
● Even in cases of a minor collision where the SRS does not deploy, the following parts should be inspected;
● Never use SRS parts from another vehicle. When replacing parts, replace with new parts.
● For the purpose of reuse, never disassemble and repair the following parts.
● If the following parts have been dropped, or have cracks, dents and other defects in their case, bracket, and connector,
replace with new one.
● Use a volt/ohmmeter with high impedance (10 kΩ/V minimum) for troubleshooting electrical circuits of the system.
● Information labels are attached to the periphery of the SRS components. Follow the instructions of the notice.
● After work on the SRS is completed, check the SRS warning light.
● If the vehicle is equipped with a mobile communication system, refer to the precaution in the IN section of the Repair Manual.
209
YARIS (EM02C4EL)
SRS
(IG)
7. 5A
IGN
A6 A12
Airbag Sensor Airbag Sensor D15
(Front RH) (Front LH) DLC3
W
B
L
7 4E
31 4E
W
W
B
W–B
Y–B
Y–B
Y–B
Y–B
Y
14 4E 30 4E
1 DQ2 2 DQ2
1 A 2 A
D+ D– D18(A), W1(B)
Y–G
Y–R
7 4M 17 4E Spiral Cable
2 1 2 B 1 B 2 1 2 1
W–B
W–B
D1 D2
210
YARIS (EM02C4EL)
D1(A), (C), (E)
(IG) Combination Meter
7. 5A
MET
SRS
LED Driver
1 4M
CPU
CAN Controller
B
CAN I/F
1 E 21 E 20 E 24 E (∗3)
1 C 21 C 20 C 24 C (∗1)
1 A 21 A 20 A 24 A (∗2)
BR
W
18 G7
D42
Junction
Connector
22 11
W
22 11
A21
Engine ECU D41
Junction
CANH CANL Connector
41 49 15 4 19 8
16
W W
AD4
W
15
L L
AD4
22 A 13 A
CANL CANH
D3
211
YARIS (EM02C4EL)
SRS
: Parts Location
Code See Page Code See Page Code See Page
46 (LHD) 48 (*1) 63 (*3)
A6 J8 B
58 (RHD) 52 (*2) 67 (*4)
D16 A
46 (LHD) 60 (*3) 51 (*1)
A12
58 (RHD) 64 (*4) 55 (*2)
J9 C
46 (LHD) 48 (*1) 63 (*3)
A21
58 (RHD) 52 (*2) 67 (*4)
D18 A
48 (*1) 60 (*3) 57 (LHD)
A J20
60 (*3) 64 (*4) 69 (RHD)
48 (*1) 49 (*1) 57 (LHD)
J21
52 (*2) 53 (*2) 69 (RHD)
D1 C D41
60 (*3) 61 (*3) 51 (*1)
64 (*4) 65 (*4) 55 (*2)
Q1
52 (*2) 49 (*1) 63 (*3)
E
64 (*4) 53 (*2) 67 (*4)
D42
48 (*1) 61 (*3) 51 (*1)
52 (*2) 65 (*4) 55 (*2)
D15 W1 B
60 (*3) 51 (*1) 63 (*3)
J8 B
64 (*4) 55 (*2) 67 (*4)
: Ground Points
Code See Page Ground Points Location
72 (*1)
73 (*2)
D1 Left Kick Panel
78 (*3)
79 (*4)
72 (*1)
73 (*2)
D2 Right Kick Panel
78 (*3)
79 (*4)
72 (*1)
D3 Instrument Panel Reinforcement Left
73 (*2)
*1: LHD Before Jan. 2009 Production *2: LHD From Jan. 2009 Production *3: RHD Before Jan. 2009 Production
*4: RHD From Jan. 2009 Production
212
YARIS (EM02C4EL)
: Ground Points
Code See Page Ground Points Location
78 (*3)
D3 Instrument Panel Reinforcement Right
79 (*4)
*1: LHD Before Jan. 2009 Production *2: LHD From Jan. 2009 Production *3: RHD Before Jan. 2009 Production
*4: RHD From Jan. 2009 Production
213
YARIS (EM02C4EL)
Seat Belt Warning
7. 5A
MET
Seat Belt
Driver' s
LED Driver
1 4M
CPU
CAN Controller
D33(A), (E), D64(B), (F), D66(D)
Main Body ECU
CAN I/F
B
DBKL CANL CANH
9 E 22 E 23 E (∗2 ∗3) 1 E 20 E 21 E 24 E (∗6)
9 A 22 A 23 A (∗2 ∗4) 1 C 20 C 21 C 24 C (∗5)
26 F (∗1 ∗3) 16 D 15 D (∗1) 1 A 20 A 21 A 24 A (∗4)
26 B (∗1 ∗4)
W
G
7 18
D42
Junction
W
Connector
5 16
5 JD1
(RHD)
(LHD)
W
2 2
+ +
Inner Belt (RH)
Inner Belt (LH)
Front Seat
Front Seat
∗ 1
: w/ Smart Entry & Start System
E E ∗ 2
: w/o Smart Entry & Start System
J35
J34
∗ 3
: From Jan. 2008 Production
1 1 ∗ 4
: Before Jan. 2008 Production
∗
(RHD)
5
: From Jan. 2008 Production
W–B
W–B W–B
(LHD)
17 JD1
W–B
W–B
15 4A 1 4S
17 4E 7 4M
W–B
W–B
1 5A (LHD)
4 5A (RHD)
D2 D1 D3
214
YARIS (EM02C4EL)
: Parts Location
Code See Page Code See Page Code See Page
48 (*1) A 60 (*3) B 61 (*3)
A
60 (*3) 48 (*1) D64 61 (*3)
F
48 (*1) D33 52 (*2) 65 (*4)
E
52 (*2) 60 (*3) 61 (*3)
D1 C D66 D
60 (*3) 64 (*4) 65 (*4)
64 (*4) 49 (*1) J34 69 (RHD)
52 (*2) 53 (*2) J35 57 (LHD)
E D42
64 (*4) 61 (*3)
D33 A 48 (*1) 65 (*4)
: Ground Points
Code See Page Ground Points Location
72 (*1)
73 (*2)
D1 Left Kick Panel
78 (*3)
79 (*4)
72 (*1)
73 (*2)
D2 Right Kick Panel
78 (*3)
79 (*4)
72 (*1)
Instrument Panel Reinforcement Left
73 (*2)
D3
78 (*3)
Instrument Panel Reinforcement Right
79 (*4)
*1: LHD Before Jan. 2009 Production *2: LHD From Jan. 2009 Production *3: RHD Before Jan. 2009 Production
*4: RHD From Jan. 2009 Production
215
YARIS (EM02C4EL)
EPS
R
(IG)
(IG)
10A
ECU–IG
7. 5A
MET
24 4B 7 4S
1 4M
B
1 E (∗8)
1 C (∗7)
1 A (∗4)
(w/o ABS)
B
P/S
LED Driver
CPU
CAN Controller
Combination Meter
D1(A), (C), (E)
16 I/F I/F CAN I/F
A37
Junction
Connector
20
17 E 16 E 21 E 20 E 24 E (∗8)
17 C 16 C 21 C 20 C 24 C (∗7)
21 A 20 A 24 A (∗4)
(w/o ABS)
(w/o ABS)
BR
SB
G
P
(w/o ABS)
8 4C
B
11 AD3
8 4D
(w/o ABS)
W–B G
P
(w/o ABS)
(w/o ABS)
W–B
B
1 3 2
IG+ SI SE
(w/o ABS)
W–B
C23
Speed Sensor
A1 D3
216
YARIS (EM02C4EL)
R
(BAT) ∗ 1 : RHD, LHD Before Jan. 2008 Production
∗ 2 : LHD From Jan. 2008 Production
∗ 3 : From Jan. 2008 Production
50A ∗ 4 : Before Jan. 2008 Production
EPS ∗ 5 : From Jan. 2009 Production
∗ 6 : Before Jan. 2009 Production
∗ 7 : From Jan. 2008 Production until Oct. 2009 Production
2 ∗ 8 : From Oct. 2009 Production
1
W
R
b1(C) c1(D) Y
Power Steering Motor Power Steering Torque Sensor
Junction Connector
D36(A), D37(B)
8 B
1 A
M
L
W
R
R
B
B
6 F (∗3) 1 A (∗1)
6 B (∗4) 1 E (∗2) 1 C 2 C 6 D 5 D 7 D 8 D
IG PIG M1 M2 TRQV TRQ1 TRQ2 TRQG
SB
W
R
Junction Connector
D34(A), D35(B)
13 A
19 A
D36(A)
Junction
Connector
20 A 20 B
W–B
(∗5)
(∗6)
BE
LG
O
3 4S
G
(w/o ABS) 7 4E
L
7 12
G 7 4 SIL TS
W 18 15
D15
DLC3
11 Y
22 W
D42
Junction Connector A3
217
YARIS (EM02C4EL)
EPS
D41
11 22 Junction Connector
4 15 1 12
(w/ ABS)
(w/ ABS)
W
W
G
L
(w/ ABS)
W
W
G
L
41 A 49 A
CANH CANL
A21(A), C20(B)
6 A 5 A (∗9) A15(A), A38(B)
Engine ECU
25 B 14 B (∗8) Skid Control ECU with Actuator
NE+ NE– CANH CANL
122 B 121 B
FL+ FL– FR+ FR– RL+ RL– RR+ RR–
9 A 8 A 31 A 30 A 11 A 12 A 33 A 34 A (∗9)
19 B 18 B 7 B 6 B 5 B 4 B 17 B 16 B (∗8)
(Shielded)
P
L
(w/ ABS)
(w/ ABS)
(w/ ABS)
(w/ ABS)
(w/ ABS)
(w/ ABS)
(w/ ABS)
(w/ ABS)
LG
G
R
C2
Crankshaft
Position
Sensor Speed Sensors
2
BR
C1
218
YARIS (EM02C4EL)
: Parts Location
Code See Page Code See Page Code See Page
46 (LHD) 52 (*2) D36 A 64 (*4)
A15 A D1 E
58 (RHD) 64 (*4) 48 (*1)
50 (*1) 48 (*1) 52 (*2)
A D37 B
62 (*3) 52 (*2) 60 (*3)
A19 D15
50 (*1) 60 (*3) 64 (*4)
E
54 (*2) 64 (*4) 49 (*1)
46 (LHD) 48 (*1) 53 (*2)
A21 A B D41
58 (RHD) 60 (*3) 61 (*3)
46 (LHD) 48 (*1) 65 (*4)
A37 D31
58 (RHD) 52 (*2) 49 (*1)
F
46 (LHD) 60 (*3) 53 (*2)
A38 B D42
58 (RHD) 64 (*4) 61 (*3)
47 (LHD) 48 (*1) 65 (*4)
C2
59 (RHD) 52 (*2) 51 (*1)
D34 A
47 (LHD) 60 (*3) 55 (*2)
C20 B b1 C
59 (RHD) 64 (*4) 63 (*3)
C23 59 (RHD) 48 (*1) 67 (*4)
48 (*1) 52 (*2) 51 (*1)
A D35 B
60 (*3) 60 (*3) 55 (*2)
c1 D
48 (*1) 64 (*4) 63 (*3)
D1
52 (*2) 48 (*1) 67 (*4)
C
60 (*3) D36 A 52 (*2)
64 (*4) 60 (*3)
: Relay Blocks
Code See Page Relay Blocks (Relay Block Location)
1 24 Engine Room R/B (Engine Compartment Left)
*1: LHD Before Jan. 2009 Production *2: LHD From Jan. 2009 Production *3: RHD Before Jan. 2009 Production
*4: RHD From Jan. 2009 Production
219
YARIS (EM02C4EL)
EPS
: Connector Joining Wire Harness and Wire Harness
Code See Page Joining Wire Harness and Wire Harness (Connector Location)
73 (*2)
AD4 78 (*3) Engine Room Main Wire and Instrument Panel Wire (Instrument Panel Left)
79 (*4)
70 (LHD)
CA2 Engine Wire and Engine Room Main Wire (Engine Compartment Left)
76 (RHD)
: Ground Points
Code See Page Ground Points Location
70 (LHD)
A1 Left Suspension Tower
76 (RHD)
72 (*1)
Left Cowl Top Side Panel
73 (*2)
A3
78 (*3)
Right Cowl Top Side Panel
79 (*4)
70 (LHD)
C1 Engine Block Left
76 (RHD)
72 (*1)
Instrument Panel Reinforcement Left
73 (*2)
D3
78 (*3)
Instrument Panel Reinforcement Right
79 (*4)
*1: LHD Before Jan. 2009 Production *2: LHD From Jan. 2009 Production *3: RHD Before Jan. 2009 Production
*4: RHD From Jan. 2009 Production
220
YARIS (EM02C4EL)
Memo
221
YARIS (EM02C4EL)
Power Window (LHD)
120A ALT
7. 5A 10A A28
ECU–B ECU–IG Fusible
Link Block
2
1
1
B
L
1 4G
16 AA2
PWR
Relay
L
30 4B
1
6 5 13 1
ECUB IG PWS GND1 20A 20A 30A
RL RR POWER
DOOR DOOR
CANP(∗3)
LIN2(∗4) DCTY
2
D33(A), (E) 4 E (∗1) 26
Main Body ECU 4 A (∗2)
21 4A 17 4E 2 4H 1 4A 19 4A 11 4H
GR
W–B
BR
SB
SB
R
SB
SB
L
Door Courtesy SW (Front LH)
1 A (∗3)
∗ 1 : From Jan. 2008 Production
1 B (∗4)
∗ 2 : Before Jan. 2008 Production
∗ 3 : Before Oct. 2009 Production
J2(A), (B)
BR
D2
222
YARIS (EM02C4EL)
G1
Power Window Master SW
B U D U D
6 16 15 12 13
GR
B
2 GD2 11 GD2 10 GD2 8 GD2 9 GD2
GR
B
11 FD2 10 FD2 11 JD1 10 JD1
W
B
2 IJ1 3 IJ1
GR
G
R
SB SB
SB
L
SB
2 FD2 5 2 1 IJ1 5 1
L 3 SB 3
F1 I1
Power Window SW Power Window SW
(Front RH) (Rear LH)
Down
Down
Up
Up
4 1 4 2
G
R
2 1 1 2
M M
F4 I2
Power Window Regulator Motor Power Window Regulator Motor
(Front RH) (Rear LH)
BR BR
223
YARIS (EM02C4EL)
Power Window (LHD)
G1
Power Window Master SW
U D U D LED+ AUTO E
10 18 8 5 3 4 1
G
R
W–B
W
G
R
R
17 GD2 18 GD2 (BAT) 10 7 5 4
U D LED AUTO
20A
D DOOR
+B S1 E
2 9 1 G8
G
R
Power Window
Regulator Motor
(Front LH)
10 4H
W–B
BR
LG
2 JD1 1 JD1
1 GD2 12 GD2
LG
G
R
BR
2 HJ1 3 HJ1
G
R
SB
SB
1 HJ1 5 1
SB 3
H1
Power Window SW
(Rear RH)
Down
Up
4 2
Y
1 2
M
H2
Power Window Regulator Motor
(Rear RH)
BR 6 5B 3 5B
D1
224
YARIS (EM02C4EL)
: Parts Location
Code See Page Code See Page Code See Page
A28 42, 46 (LHD) F4 56 (LHD) I1 56 (LHD)
A 48 (*1) G1 56 (LHD) I2 56 (LHD)
D33 48 (*1) G8 56 (LHD) A 57 (LHD)
E J2
52 (*2) H1 56 (LHD) B 57 (LHD)
F1 56 (LHD) H2 56 (LHD)
: Relay Blocks
Code See Page Relay Blocks (Relay Block Location)
1 24 Engine Room R/B (Engine Compartment Left)
: Ground Points
Code See Page Ground Points Location
72 (*1)
D1 Left Kick Panel
73 (*2)
72 (*1)
D2 Right Kick Panel
73 (*2)
*1: LHD Before Jan. 2009 Production *2: LHD From Jan. 2009 Production *3: RHD Before Jan. 2009 Production
*4: RHD From Jan. 2009 Production
225
YARIS (EM02C4EL)
Power Window (RHD)
ECU–B
120A ALT
15A 10A ∗ 4 : Before Jan. 2008 Production A28
7. 5A
AM2 ECU–IG ∗ 5 : From Jan. 2009 Production Fusible
Link
∗ 6 : Before Jan. 2009 Production Block
∗ 7 : Before Oct. 2009 Production
2 2 ∗ 8 : From Oct. 2009 Production
1
1 1B 1
B
(∗1)
GR
(∗2)
L
4 AD2 1 4G
(∗1)
GR
D36(A) 25 AA2
Junction
5 A Connector
PWR
(∗2)
L
Relay
6 A 7 A
BE(∗1 ∗5)
(∗1 ∗6)
30 4B
(∗1)
SB
O
6 F (∗3) 1
1 C 6 B (∗4) 6 5 13 1
AM1 AM2 ECUB IG PWS GND1 20A 20A 30A
RL RR POWER
DOOR DOOR
CANP(∗7)
LIN2(∗8) DCTY
2
D33(A), (E), D64(B), (F), D65(C) 23 F (∗1 ∗3) 26
Main Body ECU 23 B (∗1 ∗4)
4 E (∗2 ∗3)
4 A (∗2 ∗4) 21 4A 17 4E 2 4H 1 4A 19 4A 11 4H
GR
W–B
BR
SB
SB
R
SB
SB
L
Door Courtesy SW (Front RH)
1 A (∗7)
1 B (∗8)
J1(A), (B)
W–B
BR
D2
226
YARIS (EM02C4EL)
F7
Power Window Master SW
B U D U D
6 12 13 18 10
GR
B
2 FD2 11 FD2 10 FD2 8 FD2 9 FD2
GR
B
11 GD2 10 GD2 11 JD1 10 JD1
W
B
2 IJ1 3 IJ1
G
R
GR
SB SB
SB
L
SB
2 GD2 5 2 1 IJ1 5 1
L 3 SB 3
G7 I1
Power Window SW Power Window SW
(Front LH) (Rear LH)
Down
Down
Up
Up
4 1 4 2
G
R
2 1 1 2
M M
G4 I2
Power Window Regulator Motor Power Window Regulator Motor
(Front LH) (Rear LH)
BR BR
227
YARIS (EM02C4EL)
Power Window (RHD)
F7
Power Window Master SW
U D U D LED+ AUTO E
16 15 1 5 3 4 9
G
R
W–B
W
G
R
R
17 FD2 18 FD2 (BAT) 10 7 5 4
U D LED AUTO
20A
D DOOR
+B S1 E
2 9 1 F8
G
R
Power Window
Regulator Motor
(Front RH)
10 4H
W–B
BR
LG
2 JD1 1 JD1
1 FD2 12 FD2
LG
G
R
BR
2 HJ1 3 HJ1
G
R
SB
SB
1 HJ1 5 1
SB 3
H1
Power Window SW
(Rear RH)
Down
Up
4 2
Y
1 2
M
H2
Power Window Regulator Motor
(Rear RH)
BR 5 6B 3 6B
D2
228
YARIS (EM02C4EL)
: Parts Location
Code See Page Code See Page Code See Page
A28 42, 58 (RHD) 61 (*3) G7 68 (RHD)
D64 F
A 60 (*3) 65 (*4) H1 68 (RHD)
D33 60 (*3) 61 (*3) H2 68 (RHD)
E D65 C
64 (*4) 65 (*4) I1 68 (RHD)
60 (*3) F7 68 (RHD) I2 68 (RHD)
D36 A
64 (*4) F8 68 (RHD) A 69 (RHD)
J1
D64 B 61 (*3) G4 68 (RHD) B 69 (RHD)
: Relay Blocks
Code See Page Relay Blocks (Relay Block Location)
1 24 Engine Room R/B (Engine Compartment Left)
: Ground Points
Code See Page Ground Points Location
78 (*3)
D2 Right Kick Panel
79 (*4)
*1: LHD Before Jan. 2009 Production *2: LHD From Jan. 2009 Production *3: RHD Before Jan. 2009 Production
*4: RHD From Jan. 2009 Production
229
YARIS (EM02C4EL)
Door Lock Control (LHD)
D33(A), (E)
(BAT) (BAT) (IG) (ACC) Main Body ECU
7. 5A 25A 10A 7. 5A
ECU–B D/L ECU–IG ACC
ACC IG ALTB ECUB KSW DCTY PCTY
2 21 5 4 6 9 26 20
30 4B 7 4D 21 4A 24 4A
16
L L
AA2
R
Y
L
Door Courtesy SW (Front RH)
Door Courtesy SW (Front LH)
Unlock Warning SW
1 A (∗5) 1 A (∗5)
∗ 1 : From Jan. 2008 Production 1 1 B (∗6) 1 B (∗6)
∗ 2 : Before Jan. 2008 Production
∗ 3 : From Jan. 2009 Production
J2(A), (B)
J1(A), (B)
∗ 4 : Before Jan. 2009 Production
∗ 5 : Before Oct. 2009 Production
D19
1 6A
D2
230
YARIS (EM02C4EL)
D33(A), (E)
Main Body ECU
20 4A 5 4A 7 4A 17 4E 15 4A 15 4H 16 4H 18 4H 8 4H
O(∗4)
W–B
W–B
(∗3)
(∗3)
(∗4)
SB
BE
BE
G
O
P
L
L
Connector
6 B
Junction
5 B
(∗3)
(∗4)
BR
BR
BE
G
O
P
L
Door Courtesy SW (Rear RH)
1 A (∗5) 1 A (∗5) 7 5 6 1 4
1 B (∗6) 1 B (∗6) 12 MJ1 LSSR UL L UL L
J32(A), (B)
J33(A), (B)
Key Unlock
Detection
Key Lock
Unlock
M
BR
E
8 F5
Door Lock Assembly
15 MN1 (Front RH)
BR
W–B
2
Lock Assembly
Courtesy
Back Door
N2
W–B
W–B
1 6B
N1 D2 D2
231
YARIS (EM02C4EL)
Door Lock Control (LHD)
D33(A), (E)
Main Body ECU
LSWD LSR
21 E 24 E (∗1)
21 A 24 A (∗2)
N7(B)
Back Door Lock Assembly
L
M
(∗3)
(∗4)
BE
O
3 B 4 B
6 4H 7 4H 9 4H 17 4H 3 4A 4 4A
GR
P
7 MN1 6 MN1 8 JD2
B
GR
BR
SB
W
Y
P
L
8 MJ1 9 MJ1
GR
P
J28(A), J29(B)
9 GD1 8 GD1 7 GD1 20 GD1 10 GD1 8 B 2 B Junction Connector 7 B 1 B
(∗3)
(∗4)
BE
O
(∗3)
(∗4)
BR
BE
G
O
P
L
11 A 5 A 12 A 6 A
8 10 9 1 4 O(∗4)
LSSR UL L UL L
BE
Key Unlock
(∗3)
(∗4)
Detection
Key Lock
O
Unlock
(∗3)
GR
GR
BE
P
P
E 8 HJ1 9 HJ1 13 HJ1 8 IJ1 9 IJ1 13 IJ1
7 G5
Door Lock Assembly
(Front LH)
O(∗4)
O(∗4)
(∗3)
(∗3)
GR
GR
BE
BE
P
4 1 6 4 1 6
L UL LSSR L UL LSSR
W–B
Detection
Detection
Unlock
Unlock
M M
E E
H3 9 I3 9
Door Lock Assembly Door Lock Assembly
W–B
W–B
12 HJ1 12 IJ1
W–B
W–B
W–B W–B
1 5B 3 5B
D1
232
YARIS (EM02C4EL)
D33(A), (E)
Main Body ECU
∗ 1 : From Jan. 2008 Production
∗ 2 : Before Jan. 2008 Production
∗ 3 : From Jan. 2009 Production
∗ 4 : Before Jan. 2009 Production
L1 UL1
12 10
4 4H 5 4H
(∗3)
(∗4)
BE
LG
5 GD1 6 GD1
(∗3)
(∗4)
BR
BE
2 9
L UL
Power Window Master SW
Unlock
Lock
E
G1
1
W–B
W–B
233
YARIS (EM02C4EL)
Door Lock Control (LHD)
: Parts Location
Code See Page Code See Page Code See Page
48 (*1) H3 56 (LHD) A 57 (LHD)
D19 J32
52 (*2) I3 56 (LHD) B 57 (LHD)
A 48 (*1) A 57 (LHD) A 57 (LHD)
J1 J33
D33 48 (*1) B 57 (LHD) B 57 (LHD)
E
52 (*2) A 57 (LHD) N2 56 (LHD)
J2
F5 56 (LHD) B 57 (LHD) N7 B 56 (LHD)
G1 56 (LHD) J28 A 57 (LHD)
G5 56 (LHD) J29 B 57 (LHD)
: Relay Blocks
Code See Page Relay Blocks (Relay Block Location)
1 24 Engine Room R/B (Engine Compartment Left)
: Ground Points
Code See Page Ground Points Location
72 (*1)
D1 Left Kick Panel
73 (*2)
72 (*1)
D2 Right Kick Panel
73 (*2)
N1 74 (LHD) Back Door Panel Center
*1: LHD Before Jan. 2009 Production *2: LHD From Jan. 2009 Production *3: RHD Before Jan. 2009 Production
*4: RHD From Jan. 2009 Production
234
YARIS (EM02C4EL)
Memo
235
YARIS (EM02C4EL)
Door Lock Control (RHD)
7. 5A ECU–B
10A ECU–IG
7. 5A ACC
15A AM2
25A D/L
ACC IG ALTB ECUB AM1 AM2 KSW DCTY
2 2 21 5 4 6 1 C 6 F (∗5) 9 26
6 B (∗6)
1 1B 1
(∗1)
BE(∗1 ∗7)
GR
(∗1 ∗8)
(∗1)
SB
O
4 AD2
30 4B 7 4D 21 4A
6 A 7 A
25
L L
AA2
(∗2) (∗2) 5 A D36(A)
(∗2)
R
Y
Junction
Connector
GR
(∗1)
J1(A), (B)
D19
2
3 6A
D2
236
YARIS (EM02C4EL)
D33(A), (E), D64(B), (F), D65(C), D66(D)
Main Body ECU
24 4A 20 4A 5 4A 7 4A 17 4E 15 4A 15 4H 16 4H 9 4H 17 4H
(∗3 ∗2)
(∗3 ∗2)
W–B
W–B
(∗3)
(∗3)
SB
SB
W
G
B
L
L
Connector
6 B
Junction
5 B
Door Courtesy SW (Front LH)
(∗3 ∗2)
(∗3 ∗2)
(∗3)
(∗7)
(∗8)
BR
BR
BE
G
O
P
L
J33(A), (B)
12 MJ1
J2(A), (B)
LSSR UL
Key Unlock L UL L
Detection
Key Lock
Unlock
M
BR
E
7 G5
Door Lock Assembly
15 MN1 (Front LH)
BR
W–B
(∗3)
2
Lock Assembly
Courtesy
Back Door
N2
W–B
(∗3)
W–B
1 5B
N1 D2 D1
237
YARIS (EM02C4EL)
Door Lock Control (RHD)
LSWD LSR
25 F (∗1 ∗5) 10 D (∗1)
25 B (∗1 ∗6) N3(A), N7(B) 24 E (∗2 ∗5)
21 E (∗2 ∗5) Back Door 24 A (∗2 ∗6)
21 A (∗2 ∗6) Lock Assembly
(∗3 ∗7)
(∗3 ∗8)
BE
O
1 A 2 A (∗4)
3 B 4 B (∗3)
6 4H 7 4H 18 4H 8 4H 3 4A 4 4A
GR
P
7 MN1 6 MN1 8 JD2
B
(∗7)
(∗8)
GR
BR
BE
G
O
P
P
L
8 MJ1 9 MJ1
(∗3 ∗7)
(∗3 ∗8)
GR
BE
O
P
J28(A), J29(B)
9 FD1 8 FD1 7 FD1 20 FD1 10 FD1 8 B 2 B Junction Connector 7 B 1 B
(∗7)
(∗8)
BR
BE
G
O
P
L
11 A 5 A 12 A 6 A
O(∗3 ∗8)
7 5 6 1 4
BE
LSSR UL L UL L
(∗3 ∗7)
Key Unlock
(∗3 ∗7)
(∗3 ∗8)
Detection
Key Lock
GR
GR
BE
O
P
P
Unlock
O(∗3 ∗8)
Door Lock Assembly
(∗3 ∗7)
(∗3 ∗7)
(Front RH)
GR
GR
BE
BE
P
4 1 6 4 1 6
L UL LSSR L UL LSSR
W–B
Detection
Detection
Unlock
Unlock
M M
E E
H3 9 I3 9
Door Lock Assembly Door Lock Assembly
W–B
W–B
(∗3)
12 HJ1 12 IJ1
W–B
W–B
(∗3)
(∗3)
1 6B 3 6B
D2
238
YARIS (EM02C4EL)
D33(A), (E), D64(B), (F), D65(C), D66(D)
Main Body ECU ∗ 1 : w/ Smart Entry & Start System
∗ 2 : w/o Smart Entry & Start System
∗ 3 : w/ Theft Deterrent System
∗ 4 : w/o Theft Deterrent System
∗ 5 : From Jan. 2008 Production
L1 UL1 ∗ 6 : Before Jan. 2008 Production
∗ 7 : From Jan. 2009 Production
12 10 ∗ 8 : Before Jan. 2009 Production
4 4H 5 4H
(∗7)
(∗8)
BE
LG
5 FD1 6 FD1
(∗7)
(∗8)
BR
BE
2 8
L UL
Power Window Master SW
Unlock
Lock
E
F7
9
W–B
W–B
239
YARIS (EM02C4EL)
Door Lock Control (RHD)
: Parts Location
Code See Page Code See Page Code See Page
60 (*3) D65 C 65 (*4) J2 B 69 (RHD)
D19
64 (*4) 61 (*3) J28 A 69 (RHD)
D66 D
A 60 (*3) 65 (*4) J29 B 69 (RHD)
D33 60 (*3) F5 68 (RHD) A 69 (RHD)
E J32
64 (*4) F7 68 (RHD) B 69 (RHD)
60 (*3) G5 68 (RHD) A 69 (RHD)
D36 A J33
64 (*4) H3 68 (RHD) B 69 (RHD)
B 61 (*3) I3 68 (RHD) N2 68 (RHD)
D64 61 (*3) A 69 (RHD) N3 A 68 (RHD)
F J1
65 (*4) B 69 (RHD) N7 B 68 (RHD)
D65 C 61 (*3) J2 A 69 (RHD)
: Relay Blocks
Code See Page Relay Blocks (Relay Block Location)
1 24 Engine Room R/B (Engine Compartment Left)
: Ground Points
Code See Page Ground Points Location
78 (*3)
D1 Left Kick Panel
79 (*4)
78 (*3)
D2 Right Kick Panel
79 (*4)
N1 80 (RHD) Back Door Panel Center
*1: LHD Before Jan. 2009 Production *2: LHD From Jan. 2009 Production *3: RHD Before Jan. 2009 Production
*4: RHD From Jan. 2009 Production
240
YARIS (EM02C4EL)
Memo
241
YARIS (EM02C4EL)
Wireless Door Lock Control (LHD)
D33(A), (E)
(BAT) (BAT) (IG) (ACC) Main Body ECU
7. 5A 25A 10A 7. 5A
ECU–B D/L ECU–IG ACC
ACC IG ALTB ECUB KSW DCTY PCTY
2 21 5 4 6 9 26 20
30 4B 7 4D 21 4A 24 4A
16
L L
AA2
R
Y
L
Door Courtesy SW (Front RH)
Door Courtesy SW (Front LH)
Unlock Warning SW
1 A (∗5) 1 A (∗5)
1 1 B (∗6) 1 B (∗6)
J2(A), (B)
J1(A), (B)
D19
1 6A
D2
242
YARIS (EM02C4EL)
D33(A), (E)
Main Body ECU
20 4A 5 4A 7 4A 17 4E
W–B 15 4A 18 4H 8 4H
W–B
(∗3)
(∗4)
SB
BE
G
O
P
L
L
Connector
6 B
Junction
5 B
(∗3)
(∗4)
BR
BE
O
P
L
Door Courtesy SW (Rear RH)
1 A (∗5) 1 A (∗5) 7 1 4
1 B (∗6) 1 B (∗6) 12 MJ1 LSSR UL L
J32(A), (B)
J33(A), (B)
Detection
Unlock
M
BR
E
8 F5
Door Lock Assembly
15 MN1 (Front RH)
BR
W–B
2
Lock Assembly
Courtesy
Back Door
N2
1
W–B
W–B
1 6B
N1 D2 D2
243
YARIS (EM02C4EL)
Wireless Door Lock Control (LHD)
D33(A), (E)
Main Body ECU
LSWD LSR
21 E 24 E (∗1)
21 A 24 A (∗2)
N7
Back Door Lock Assembly
L
M
(∗3)
(∗4)
BE
O
3 4
9 4H 17 4H 3 4A 4 4A
GR
P
7 MN1 6 MN1 8 JD2
GR
SB
P
L
B
8 MJ1 9 MJ1
GR
P
9 GD1 20 GD1 10 GD1 J28(A), J29(B)
8 B 2 B Junction Connector 7 B 1 B
(∗3)
(∗4)
BE
O
(∗3)
(∗4)
BE
O
P
L
11 A 5 A 12 A 6 A
8 1 4
O
LSSR UL L
(∗4)
Detection
BE
Unlock
M
(∗3)
(∗4)
O
(∗3)
GR
GR
BE
P
E
7 G5
Door Lock Assembly 8 HJ1 9 HJ1 13 HJ1 8 IJ1 9 IJ1 13 IJ1
(Front LH)
O(∗4)
O(∗4)
(∗3)
(∗3)
GR
GR
BE
BE
P
4 1 6 4 1 6
L UL LSSR L UL LSSR
W–B
Detection
Detection
Unlock
Unlock
M M
E E
H3 9 I3 9
Door Lock Assembly Door Lock Assembly
W–B
W–B
12 HJ1 12 IJ1
W–B
W–B
1 5B
D1
244
YARIS (EM02C4EL)
D33(A), (E)
Main Body ECU
8
EHW
(BAT) FLASHER
Relay
15A 2 4K
DOME
1
P
L
13 4B
4 4P 5 4K
L
R
L
1
Room Lamp (Center)
1 B
D38(A), D39(B)
Door
Junction
Off
On
Connector
8 A
K2
3 2
W–B
R
L
5 3 2
+B PRG RDA
GND
J13 1
Door Control Receiver
∗ 1 : From Jan. 2008 Production
∗ 2 : Before Jan. 2008 Production
∗ 3 : From Jan. 2009 Production
∗ 4 : Before Jan. 2009 Production
W–B
J2
245
YARIS (EM02C4EL)
Wireless Door Lock Control (LHD)
: Parts Location
Code See Page Code See Page Code See Page
48 (*1) F5 56 (LHD) J28 A 57 (LHD)
D19
52 (*2) G5 56 (LHD) J29 B 57 (LHD)
A 48 (*1) H3 56 (LHD) A 57 (LHD)
J32
D33 48 (*1) I3 56 (LHD) B 57 (LHD)
E
52 (*2) A 57 (LHD) A 57 (LHD)
J1 J33
48 (*1) B 57 (LHD) B 57 (LHD)
D38 A
52 (*2) A 57 (LHD) K2 56 (LHD)
J2
48 (*1) B 57 (LHD) N2 56 (LHD)
D39 B
52 (*2) J13 57 (LHD) N7 56 (LHD)
: Relay Blocks
Code See Page Relay Blocks (Relay Block Location)
1 24 Engine Room R/B (Engine Compartment Left)
: Ground Points
Code See Page Ground Points Location
72 (*1)
D1 Left Kick Panel
73 (*2)
72 (*1)
D2 Right Kick Panel
73 (*2)
J2 74 (LHD) Left Rear Quarter Panel
N1 74 (LHD) Back Door Panel Center
*1: LHD Before Jan. 2009 Production *2: LHD From Jan. 2009 Production *3: RHD Before Jan. 2009 Production
*4: RHD From Jan. 2009 Production
246
YARIS (EM02C4EL)
Memo
247
YARIS (EM02C4EL)
Wireless Door Lock Control (RHD w/o Smart Entry & Start System)
D33(A), (E)
(BAT) (BAT) (IG) (ACC) Main Body ECU
7. 5A 25A 10A 7. 5A
ECU–B D/L ECU–IG ACC
ACC IG ALTB ECUB KSW DCTY PCTY
2 21 5 4 6 9 26 20
30 4B 7 4D 21 4A 24 4A
25
L L
AA2
R
Y
L
Door Courtesy SW (Front RH)
J1(A), (B)
J2(A), (B)
D19
2
∗ 1 : From Jan. 2008 Production
∗ 2 : Before Jan. 2008 Production
∗ 3 : From Jan. 2009 Production
∗ 4 : Before Jan. 2009 Production
∗ 5 : Before Oct. 2009 Production
∗ 6 : From Oct. 2009 Production
W–B
3 6A
D2
248
YARIS (EM02C4EL)
D33(A), (E)
Main Body ECU
20 4A 5 4A 7 4A 17 4E
W–B 15 4A 9 4H 17 4H
W–B
SB
SB
W
G
L
L
Connector
6 B
Junction
J29(B)
(∗3)
(∗4)
BE
O
P
L
1 A (∗5) 1 A (∗5)
1 B (∗6) 1 B (∗6) 12 MJ1 8 1 4
LSSR UL L
J32(A), (B)
J33(A), (B)
Detection
Unlock
M
BR
E
7 G5
15 MN1 Door Lock Assembly
(Front LH)
BR
W–B
2
Lock Assembly
Courtesy
Back Door
N2
1
W–B
W–B
1 5B
N1 D2 D1
249
YARIS (EM02C4EL)
Wireless Door Lock Control (RHD w/o Smart Entry & Start System)
D33(A), (E)
Main Body ECU
LSWD LSR
21 E 24 E (∗1)
21 A 24 A (∗2)
N7
Back Door Lock Assembly
L
M
(∗3)
(∗4)
BE
O
3 4
18 4H 8 4H 3 4A 4 4A
GR
P
7 MN1 6 MN1 8 JD2
B
(∗3)
(∗4)
GR
BE
O
P
P
L
8 MJ1 9 MJ1
GR
P
J28(A), J29(B)
9 FD1 20 FD1 10 FD1 8 B 2 B Junction Connector 7 B 1 B
(∗3)
(∗4)
BE
O
(∗3)
(∗4)
BE
O
P
L
11 A 5 A 12 A 6 A
7 1 4 O
LSSR UL L (∗4)
BE
Detection
(∗3)
Unlock
(∗4)
M
O
(∗3)
GR
GR
BE
P
E
8 F5 8 HJ1 9 HJ1 13 HJ1 8 IJ1 9 IJ1 13 IJ1
Door Lock Assembly
(Front RH)
O(∗4)
O(∗4)
(∗3)
(∗3)
GR
GR
BE
BE
P
4 1 6 4 1 6
L UL LSSR L UL LSSR
Detection
Detection
W–B
Unlock
Unlock
M M
E E
H3 9 I3 9
Door Lock Assembly Door Lock Assembly
W–B
W–B
12 HJ1 12 IJ1
W–B
W–B
1 6B
D2
250
YARIS (EM02C4EL)
D33(A), (E)
Main Body ECU
(BAT) 2 4K 8 4R
15A
DOME
B
2
8
1 HAZ
P
L
D71
Turn Signal
Flasher
13 4B
4 4P 5 4K
L
R
L
1
Room Lamp (Center)
1 B
D38(A), D39(B)
Door
Junction
Off
On
Connector
8 A
K2
3 2
W–B
R
L
5 3 2
+B PRG RDA
GND
J2
251
YARIS (EM02C4EL)
Wireless Door Lock Control (RHD w/o Smart Entry & Start System)
: Parts Location
Code See Page Code See Page Code See Page
60 (*3) D71 65 (*4) J28 A 69 (RHD)
D19
64 (*4) F5 68 (RHD) J29 B 69 (RHD)
A 60 (*3) G5 68 (RHD) A 69 (RHD)
J32
D33 60 (*3) H3 68 (RHD) B 69 (RHD)
E
64 (*4) I3 68 (RHD) A 69 (RHD)
J33
60 (*3) A 69 (RHD) B 69 (RHD)
D38 A J1
64 (*4) B 69 (RHD) K2 68 (RHD)
60 (*3) A 69 (RHD) N2 68 (RHD)
D39 B J2
64 (*4) B 69 (RHD) N7 68 (RHD)
D71 61 (*3) J13 69 (RHD)
: Relay Blocks
Code See Page Relay Blocks (Relay Block Location)
1 24 Engine Room R/B (Engine Compartment Left)
: Ground Points
Code See Page Ground Points Location
78 (*3)
D1 Left Kick Panel
79 (*4)
78 (*3)
D2 Right Kick Panel
79 (*4)
J2 80 (RHD) Left Rear Quarter Panel
*1: LHD Before Jan. 2009 Production *2: LHD From Jan. 2009 Production *3: RHD Before Jan. 2009 Production
*4: RHD From Jan. 2009 Production
252
YARIS (EM02C4EL)
: Ground Points
Code See Page Ground Points Location
N1 80 (RHD) Back Door Panel Center
253
YARIS (EM02C4EL)
Theft Deterrent (LHD)
D33(A), (E)
(BAT) (BAT) (IG) (ACC) Main Body ECU
7. 5A 25A 10A 7. 5A
ECU–B D/L ECU–IG ACC
ACC IG ALTB ECUB HAZ DCTY PCTY
2 21 5 4 6 25 26 20
8
EHW
FLASHER
Relay
30 4B 21 4A 24 4A
16
L L
AA2
L
Door Courtesy SW (Front RH)
Door Courtesy SW (Front LH)
1 A (∗5) 1 A (∗5)
1 B (∗6) 1 B (∗6)
J2(A), (B)
J1(A), (B)
∗ 1 : From Jan. 2008 Production
∗ 2 : Before Jan. 2008 Production
∗ 5 : Before Oct. 2009 Production
∗ 6 : From Oct. 2009 Production
254
YARIS (EM02C4EL)
J32(A), (B)
Door Courtesy SW (Rear RH)
22
L
20 4A
RRCY
1 B (∗6)
1 A (∗5)
J33(A), (B)
Door Courtesy SW (Rear LH)
G
5 4A
1 B (∗6)
1 A (∗5)
N2
Back Door Lock Assembly
Courtesy
1
2
23
W–B BR BR BR SB
5 B
6 B
7 4A
N1
12 MJ1
15 MN1
BCTY
J29(B)
Junction
Connector
1
W–B
17 4E
D2
GND1
W–B
15 4A
D33(A), (E)
Main Body ECU
Unlock
YARIS (EM02C4EL)
Detection
8
E
7
LSSR
W–B L L
5 A
5 E
1 6B
D2
9 FD1
LSWP
F5
Door Lock Assembly
(Front RH)
Unlock
Detection
7
E
8
LSSR
W–B L L
1 5B
D1
9 GD1
LSWD
21 A (∗2)
21 E (∗1)
G5
Door Lock Assembly
(Front LH)
W–B
255
Theft Deterrent (LHD)
D33(A), (E)
Main Body ECU
(∗3)
(∗4)
BE
O
8 JD2
(∗3)
(∗4)
BE
L
O
(∗4)
BE
W
L
(∗3)
(∗3)
(∗4)
BE
1 B
D38(A), D39(B)
Junction
Connector
13 HJ1 13 IJ1 8 A
L
(∗3)
(∗4)
(∗3)
(∗4)
BE
BE
O
LSSR LSSR
Detection
Detection
L
Unlock
Unlock
(Rear RH)
(Rear LH)
3 2 5
E E PRG RDA +B
H3
I3
9 9
W–B
W–B
12 HJ1 12 IJ1
GND
J13 1
W–B
W–B
W–B W–B
W–B
J2
256
YARIS (EM02C4EL)
D33(A), (E)
Main Body ECU
10A
H–LP LH/ 7 4D 6 4E 2 4K
GR
L
H–LP LO LH
2
1
1
P
Door
Off
On
K2
Y
Y
3 2
W–B
L
L L
8
D40
GR
Junction
Unlock Warning SW
Connector
2 1
6
5 1
D19
Y
H–LP/AMT 2
Relay
3 2
3 4J
17 4B
V
W–B
D2
257
YARIS (EM02C4EL)
Theft Deterrent (LHD)
D33(A), (E)
Main Body ECU (BAT) (BAT) (BAT)
120A ALT
10A 15A
Link Block
HORN DOME
Fusible
SRX STX HORN TRLY
A28
18 E 19 E (∗1) 15 19 1 2 2
18 A 19 A (∗2)
1
T–LP Relay
B
HORN
L
Relay
(∗3)
(∗4)
BE
O
P
28 4B 1 4G 7 1A
13 4B
LG
5 4K 4 4P 5 4P
B
L
L
L
D74
Theft Warning ECU 11
+B1
O LG
P
(∗4)
G
BE
(∗3)
18 16
D35
Junction
Connector
258
YARIS (EM02C4EL)
(BAT) (IG)
7. 5A 10A
W–B
ECU–B ECU–IG
1
2
LSWE
1 7 4S
Detection
Lock Assembly
Unlock
L
Back Door
W–B W–B
16 AA2 BD+
N7
R
W–B
L
P
30 4B 1 2
12 MN1 L
A33 A34
Engine Hood Security
Courtesy SW Horn
P
12 4H B
2 1
15 MJ1
P
D36(A), D37(B)
(∗3)
(∗4)
BE
W
O
Junction
11 A Connector
P
3 B 9 B 8 B
(∗3)
(∗4)
(∗3)
(∗4)
BE
BE
O
O
GR
BR
13 9 6 4 15
+B2 IG LSR(∗5) DSWH SH–
LUG(∗6)
E
16 D74
Theft Warning ECU
LG
2
W–B
D25
Security
Indicator Lamp
6
W–B
5
W–B 10 D40
Junction
Connector
11
W–B
W–B
W–B
3 5A
D1 A1 N1
259
YARIS (EM02C4EL)
Theft Deterrent (LHD)
: Parts Location
Code See Page Code See Page Code See Page
A28 42, 46 (LHD) 48 (*1) A 57 (LHD)
D37 B J1
A33 46 (LHD) 52 (*2) B 57 (LHD)
A34 46 (LHD) 48 (*1) A 57 (LHD)
D38 A J2
48 (*1) 52 (*2) B 57 (LHD)
D19
52 (*2) 48 (*1) J13 57 (LHD)
D39 B
48 (*1) 52 (*2) J29 B 57 (LHD)
D25
52 (*2) 49 (*1) A 57 (LHD)
D40 J32
A 48 (*1) 53 (*2) B 57 (LHD)
D33 48 (*1) 49 (*1) A 57 (LHD)
E D74 J33
52 (*2) 53 (*2) B 57 (LHD)
48 (*1) F5 56 (LHD) K2 56 (LHD)
D35
52 (*2) G5 56 (LHD) N2 56 (LHD)
48 (*1) H3 56 (LHD) N7 56 (LHD)
D36 A
52 (*2) I3 56 (LHD)
: Relay Blocks
Code See Page Relay Blocks (Relay Block Location)
1 24 Engine Room R/B (Engine Compartment Left)
2 28 Engine Room R/B No.2 (Engine Compartment Right)
*1: LHD Before Jan. 2009 Production *2: LHD From Jan. 2009 Production *3: RHD Before Jan. 2009 Production
*4: RHD From Jan. 2009 Production
260
YARIS (EM02C4EL)
: Connector Joining Wire Harness and Wire Harness
Code See Page Joining Wire Harness and Wire Harness (Connector Location)
MJ1 74 (LHD) Back Door No.1 Wire and Floor Wire (Left Rear Quarter Panel)
MN1 74 (LHD) Back Door No.1 Wire and Back Door No.2 Wire (Back Door Panel Center)
: Ground Points
Code See Page Ground Points Location
A1 70 (LHD) Left Suspension Tower
72 (*1)
D1 Left Kick Panel
73 (*2)
72 (*1)
D2 Right Kick Panel
73 (*2)
J2 74 (LHD) Left Rear Quarter Panel
N1 74 (LHD) Back Door Panel Center
*1: LHD Before Jan. 2009 Production *2: LHD From Jan. 2009 Production *3: RHD Before Jan. 2009 Production
*4: RHD From Jan. 2009 Production
261
YARIS (EM02C4EL)
Theft Deterrent (RHD)
7. 5A ECU–B
10A ECU–IG
7. 5A ACC
15A AM2
25A D/L
ACC IG ALTB ECUB AM1 AM2 HAZ DCTY
2 2 21 5 4 6 1 C 6 F (∗5) 25 26
6 B (∗6)
1 1B 1
BE(∗1 ∗7)
(∗1 ∗8)
(∗1)
(∗1)
GR
SB
O
4 AD2
30 4B 6 A 7 A 8 4R 21 4A
25 5 A D36(A)
B
L L Junction
AA2 Connector
(∗2) (∗2)
R
GR 8
(∗1) HAZ
D71
Turn Signal
Flasher
262
YARIS (EM02C4EL)
J2(A), (B)
Door Courtesy SW (Front LH)
20
L
24 4A
PCTY
1 A (∗9)
1 B (∗10)
J32(A), (B)
Door Courtesy SW (Rear RH) 22
L
20 4A
RRCY
1 A (∗9)
1 B (∗10)
J33(A), (B)
Door Courtesy SW (Rear LH)
G
5 4A
1 A (∗9)
1 B (∗10)
N2
Back Door Lock Assembly
Courtesy
1
2
23
W–B BR BR BR SB
5 B
6 B
7 4A
N1
12 MJ1
15 MN1
BCTY
J29(B)
Junction Connector
1
W–B
17 4E
D2
GND1
Main Body ECU
W–B
15 4A
YARIS (EM02C4EL)
H3
Door Lock Assembly
(Rear RH) BE
(∗7)
D33(A), (E), D64(B), (F), D65(C), D66(D)
Unlock
Detection
9
6
W–B W–B O
12 HJ1
13 HJ1
E
(∗8)
LSSR
O
BE
(∗7)
(∗8)
BE
W–B
(∗7)
Unlock
12
13
Detection
9
6
W–B W–B O BE BE BE
IJ1
IJ1
8 JD2
LSR
E
(∗8) (∗7) (∗7) (∗7)
10 D (∗1)
LSSR
O O O
24 A (∗2 ∗6)
24 E (∗2 ∗5)
263
Theft Deterrent (RHD)
2
L
GR
(∗3)
(∗3)
B
B
9 GD1 9 FD1
L
7 7
8 7 5 1
5 1 8
LSSR LSSR
D40
DIM Junction
Relay H–LP Connector
Detection
Detection
Door Lock Assembly
Relay
Unlock
Unlock
6
3 2
3 2
(Front RH)
(Front LH)
7 7
Y
E E 7
G5
F5
B
7 8
(∗3)
(∗3)
V
B 3 4J
(∗3)
B
(∗3) 17 4B
V
W–B
W–B
(∗4)
1 5B 1 6B
D1 D2
264
YARIS (EM02C4EL)
D33(A), (E), D64(B), (F), D65(C), D66(D)
Main Body ECU
10A
H–LP LH/ 7 4D 6 4E 2 4K
L
H–LP LO LH
2
1
1
P
Door
Off
On
(∗2)
K2
Y
3 2
W–B
(∗4)
GR
2 L
L
5 1 (∗2)
H–LP/AMT
Relay
(∗2)
(∗2)
(∗2)
W
3 2
1 B
Unlock Warning SW
2
1 D38(A), D39(B)
Junction
Connector
(∗4)
V
8 A
D19
(∗2)
L
(∗2)
(∗2)
W
3 2 5
PRG RDA +B
W–B
(∗2)
GND
J13 1
Door Control
Receiver
W–B
(∗2)
Y
3 6A
D2 J2
265
YARIS (EM02C4EL)
Theft Deterrent (RHD)
120A ALT
10A 15A
Link Block
HORN DOME
Fusible
CANL CANH SRX STX HORN TRLY
A28
16 D 15 D 18 E 19 E (∗5) 15 19 1 2 2
18 A 19 A (∗6)
1
T–LP Relay
B
HORN
L
(∗2 ∗7)
(∗2 ∗8)
Relay
(∗1)
(∗1)
(∗2)
BE
W
O
R
P
Junction Connector
28 4B 1 4G 7 1A
16 5
13 4B
D42
17 6
LG 5 4K 4 4P 5 4P
(∗2)
B
L
L
L
L
(∗2)
D74
Theft Warning ECU 11
+B1
(∗1)
(∗1)
GR
W
Y
BE(∗2 ∗7)
(∗1 ∗7)
(∗1 ∗8)
P(∗2)
P(∗1)
BE
28 27 25 24
CANL CANH SECO SECI
(∗1)
(∗1)
(∗1)
LG
W
R
L
LG
14 JD1 15 JD1 16 JD1 (∗1)
(∗1)
(∗1)
(∗1)
W
R
L
4 5 2
+5 DATA RSSI J13
Door Control Receiver
GND
1
Y
W–B
(∗1)
J2
266
YARIS (EM02C4EL)
(BAT) (IG)
7. 5A 10A
W–B
(∗2)
ECU–B ECU–IG
1
2
LSWE
1 7 4S
Detection
Lock Assembly
W–B W–B
Unlock
L
Back Door
25 AA2 BD+
W–B
N7
R
2
L
(∗2)
P
1 2
30 4B L
12 MN1 A33 A34
Engine Hood Security
Courtesy SW Horn
(∗2) B
P
12 4H 2 1
15 MJ1
P
(∗7)
(∗8)
D36(A), D37(B)
BE
W
O
Junction
11 A Connector
(∗2)
P
3 B 9 B 8 B
BE(∗2 ∗7)
(∗2 ∗8)
(∗7)
(∗8)
BE
W
O
O
GR
BR
D74
13 9 Theft Warning ECU 6 4 15
+B2 IG LSR(∗9) DSWH SH–
LUG(∗10)
IND E
29 16
LG
G
2
W–B
18 16
D35
Junction D25
Connector Security
17 Indicator Lamp
(∗1)
LG
W–B
LG (∗1)
W–B
(∗2)
(∗1)
5
W–B 10 D40
Junction
Connector
11
∗ 1 : w/ Smart Entry & Start System
W–B
W–B
(∗2)
W–B
∗ 7 : From Jan. 2009 Production
∗ 8 : Before Jan. 2009 Production (∗1)
∗ 9 : Before Oct. 2009 Production
W–B
(∗1)
D1 D2 A1 N1
267
YARIS (EM02C4EL)
Theft Deterrent (RHD)
: Parts Location
Code See Page Code See Page Code See Page
A28 42, 58 (RHD) D39 B 64 (*4) G5 68 (RHD)
A33 58 (RHD) 61 (*3) H3 68 (RHD)
D40
A34 58 (RHD) 65 (*4) I3 68 (RHD)
60 (*3) 61 (*3) A 69 (RHD)
D19 D42 J1
64 (*4) 65 (*4) B 69 (RHD)
60 (*3) 61 (*3) A 69 (RHD)
D25 D60 J2
64 (*4) 65 (*4) B 69 (RHD)
A 60 (*3) B 61 (*3) J13 69 (RHD)
D33 D64
E 64 (*4) F 65 (*4) J29 B 69 (RHD)
60 (*3) 61 (*3) A 69 (RHD)
D35 D65 C J32
64 (*4) 65 (*4) B 69 (RHD)
60 (*3) 61 (*3) A 69 (RHD)
D36 A D66 D J33
64 (*4) 65 (*4) B 69 (RHD)
60 (*3) 61 (*3) K2 68 (RHD)
D37 B D71
64 (*4) 65 (*4) N2 68 (RHD)
60 (*3) 61 (*3) N7 68 (RHD)
D38 A D74
64 (*4) 65 (*4)
D39 B 60 (*3) F5 68 (RHD)
: Relay Blocks
Code See Page Relay Blocks (Relay Block Location)
1 24 Engine Room R/B (Engine Compartment Left)
2 28 Engine Room R/B No.2 (Engine Compartment Right)
7 29 Engine Room R/B No.7 (Engine Compartment Right)
*1: LHD Before Jan. 2009 Production *2: LHD From Jan. 2009 Production *3: RHD Before Jan. 2009 Production
*4: RHD From Jan. 2009 Production
268
YARIS (EM02C4EL)
: Connector Joining Wire Harness and Wire Harness
Code See Page Joining Wire Harness and Wire Harness (Connector Location)
FD1 79 (*4) Front Door RH Wire and Instrument Panel Wire (Right Kick Panel)
78 (*3)
GD1 Front Door LH Wire and Instrument Panel Wire (Left Kick Panel)
79 (*4)
HJ1 80 (RHD) Rear Door No.1 Wire and Floor Wire (Right Center Pillar)
IJ1 80 (RHD) Rear Door No.2 Wire and Floor Wire (Left Center Pillar)
78 (*3)
JD1
79 (*4)
Floor Wire and Instrument Panel Wire (Instrument Panel Left)
78 (*3)
JD2
79 (*4)
MJ1 80 (RHD) Back Door No.1 Wire and Floor Wire (Left Rear Quarter Panel)
MN1 80 (RHD) Back Door No.1 Wire and Back Door No.2 Wire (Back Door Panel Center)
: Ground Points
Code See Page Ground Points Location
A1 76 (RHD) Left Suspension Tower
78 (*3)
D1 Left Kick Panel
79 (*4)
78 (*3)
D2 Right Kick Panel
79 (*4)
J2 80 (RHD) Left Rear Quarter Panel
N1 80 (RHD) Back Door Panel Center
*1: LHD Before Jan. 2009 Production *2: LHD From Jan. 2009 Production *3: RHD Before Jan. 2009 Production
*4: RHD From Jan. 2009 Production
269
YARIS (EM02C4EL)
Front Wiper and Washer
(IG)
15A
WSH
2 4B
B
L(LHD)
(RHD)
L
Y
2
Connector
Junction
Y
L
A26
+B INT1 INT2 +S +1 +2 B1
MIST Washer SW
1
A5
Wiper SW
OFF WF EW
Windshield
M Washer
Motor INT Off
2
LO On
HI
G
1 AD2
+S INT1 INT2 B1
G
(∗1)
(∗2)
(∗1)
+B +S W E
Wiper Relay
+S +B WF EW
1 D 2 D 3 C 2 C (LHD)
4 B 3 B 1 A 2 A (RHD)
W–B
G
W–B
270
YARIS (EM02C4EL)
(IG)
∗ 1 : w/ INT Time SW
∗ 2 : w/o INT Time SW
20A
WIP
1 4H 36 4B
B B
B
Y
L 4 4E
5 AD2 2 AD2 25 4B
W
Y
3 A 5 A 1 A 2 A (LHD)
4 B 1 B 3 B 2 B (RHD)
+2 +1 +S B
E
4 A (LHD) A9(A), (B)
5 B (RHD) Windshield Wiper Motor
W–B
W–B
2 4E
17 4E
W–B
W–B
D2 A1
271
YARIS (EM02C4EL)
Front Wiper and Washer
: Parts Location
Code See Page Code See Page Code See Page
46 (LHD) A26 66 (*4) 60 (*3)
A5 B
58 (RHD) 60 (*3) 64 (*4)
A D6
A 46 (LHD) 64 (*4) 48 (*1)
A9 D5 D
B 58 (RHD) 48 (*1) 52 (*2)
C
A26 62 (*3) 52 (*2)
: Ground Points
Code See Page Ground Points Location
70 (LHD)
A1 Left Suspension Tower
76 (RHD)
72 (*1)
73 (*2)
D2 Right Kick Panel
78 (*3)
79 (*4)
*1: LHD Before Jan. 2009 Production *2: LHD From Jan. 2009 Production *3: RHD Before Jan. 2009 Production
*4: RHD From Jan. 2009 Production
272
YARIS (EM02C4EL)
Memo
273
YARIS (EM02C4EL)
Rear Wiper and Washer
(IG) (IG)
D5(A), (C), D6(B), (D)
Windshield Wiper SW Assembly
15A 15A
RR WIP WSH WR +1R EW
Washer SW
Off
25 4A 2 4B
On
On+Washer
W
(RHD)
L
5 D 7 C 2 C (LHD)
2 10 B 4 A 2 A (RHD)
A26
4 MJ1 Junction
(LHD)
W–B
Connector
L
1
(RHD)
L
18 JD1
BE(∗1)
O(∗2)
1
L
A4
W
6 MJ1
2
L
L
10 AD2
2 MN1 9 MN1
BE(∗1)
L
O(∗2)
W
1 2
B L
N1
M Rear Wiper Motor
Assembly
2 4E
17 4E
∗ 1 : From Jan. 2009 Production
∗ 2 : Before Jan. 2009 Production
W–B
D2
274
YARIS (EM02C4EL)
: Parts Location
Code See Page Code See Page Code See Page
46 (LHD) A 64 (*4) 48 (*1)
A4 D6 D
58 (RHD) D5 48 (*1) 52 (*2)
C
62 (*3) 52 (*2) 56 (LHD)
A26 N1
66 (*4) 60 (*3) 68 (RHD)
D6 B
D5 A 60 (*3) 64 (*4)
: Ground Points
Code See Page Ground Points Location
72 (*1)
73 (*2)
D2 Right Kick Panel
78 (*3)
79 (*4)
*1: LHD Before Jan. 2009 Production *2: LHD From Jan. 2009 Production *3: RHD Before Jan. 2009 Production
*4: RHD From Jan. 2009 Production
275
YARIS (EM02C4EL)
Shift Lock
7. 5A ACC2
10A 10A D43(A), (B)
GAUGE STOP Fuse Block
3 A (LHD)
2 4P 18 4B 2 B (RHD)
B
2
A13
Stop
Lamp SW
(∗1)
R
B
1
G
12 4B
18 4S
G
1 B 7 B 6 B (∗2)
1 A 7 A 6 A (∗3)
IG STP ACC
D22(A), (B)
Shift Lock
Control ECU
W–B
(∗1)
L
1
Key Interlock
Solenoid
D13
12
W–B 5 D40
Junction
(∗1) Connector
11
∗ 1 : w/o Smart Entry & Start System
∗ 2 : From Jan. 2008 Production
∗ 3 : Before Jan. 2008 Production
W–B
3 5A (LHD)
1 5A (RHD)
D1
276
YARIS (EM02C4EL)
: Parts Location
Code See Page Code See Page Code See Page
50 (*1) 48 (*1) 61 (*3)
A D40
54 (*2) 60 (*3) 65 (*4)
A13
62 (*3) 48 (*1) 44, 49 (*1)
D22 A
66 (*4) 52 (*2) 44, 53 (*2)
B D43
48 (*1) 60 (*3) 44, 61 (*3)
B
52 (*2) 64 (*4) 44, 65 (*4)
D13
60 (*3) 49 (*1)
D40
64 (*4) 53 (*2)
: Ground Points
Code See Page Ground Points Location
72 (*1)
73 (*2)
D1 Left Kick Panel
78 (*3)
79 (*4)
*1: LHD Before Jan. 2009 Production *2: LHD From Jan. 2009 Production *3: RHD Before Jan. 2009 Production
*4: RHD From Jan. 2009 Production
277
YARIS (EM02C4EL)
Remote Control Mirror
(ACC)
7. 5A 13 B
ACC
D34(A), D35(B)
Junction
Connector
19 A
6 4S
GR
GR
D12
8 Outer Mirror SW
B
W–B 7 E
Operation
Right/
Down
Down
Right
Left/
SW
Left
Up
Up
MH MV
Select SW
Left Right Left Right
HL HR VL VR M+
5 2 4 3 6
SB
B
(∗2)
(∗3)
BE
SB
P
12 FD1 13 FD1
SB
MH MV
3 A 5 A (∗3)
M
4 B 9 B (∗2)
M M
Outer Rear View Mirror (LH)
MH MV 13 17 6
F2(A), F9(B)
(∗1)
M
W
M M MR MF M+ L
G2(A), G9(B)
1 A 2 A 4 A (∗3)
7 B 2 B 8 B (∗2) 14 FD1
MR MF M+
(∗1)
(∗1)
LG
L
1 A 2 A 4 A (∗3)
7 B 2 B 8 B (∗2)
16 FD1 15 FD1
W
(∗1)
(∗1)
LG
W
L
(∗1)
L
BE(∗1 ∗2)
16 GD1 15 GD1
O(∗1 ∗3)
(∗1)
(∗1)
BR
LG
W
W–B
LG(∗1)
BR
(∗1)
4 6A (LHD)
5 6A (RHD)
D2
278
YARIS (EM02C4EL)
∗ 1 : w/ Retractor
∗ 2 : From Jan. 2009 Production
∗ 3 : Before Jan. 2009 Production
D12
Outer Mirror SW
Retractor SW
Retraction Return
MF MR
10 9
(∗1)
(∗1)
LG
18 7
D38
Junction
Connector
12 16 5
(∗1)
(∗1)
BR
LG
G
14 GD1
W
LG(∗1)
BR
(∗1)
279
YARIS (EM02C4EL)
Remote Control Mirror
: Parts Location
Code See Page Code See Page Code See Page
48 (*1) 48 (*1) 56 (LHD)
F2 A
52 (*2) 52 (*2) 68 (RHD)
D12 D35 B
60 (*3) 60 (*3) 56 (LHD)
F9 B
64 (*4) 64 (*4) 68 (RHD)
48 (*1) 48 (*1) 56 (LHD)
G2 A
52 (*2) 52 (*2) 68 (RHD)
D34 A D38
60 (*3) 60 (*3) 56 (LHD)
G9 B
64 (*4) 64 (*4) 68 (RHD)
: Ground Points
Code See Page Ground Points Location
72 (*1)
73 (*2)
D2 Right Kick Panel
78 (*3)
79 (*4)
*1: LHD Before Jan. 2009 Production *2: LHD From Jan. 2009 Production *3: RHD Before Jan. 2009 Production
*4: RHD From Jan. 2009 Production
280
YARIS (EM02C4EL)
Memo
281
YARIS (EM02C4EL)
Rear Window Defogger
30A 10A 7. 5A
DEF GAUGE A/C
DEF
Relay
2 4F 12 4Q 10 4S
O
B
(∗5)
(∗5)
(∗4)
BE
B
12 DE1
20 JD2 15
D88
(∗4)
(∗5)
15 DE1
O
B
Junction
Connector
B
15
17 E10
Junction
Connector
(∗4)
P
(∗5)
B
17
P
(∗5)
2 A 3 A (∗1)
B
2 B 3 B (∗2)
D98(D), E6(A), (B), (C) 2 C 3 C (∗6)
Rear Window Defogger SW 2 D 3 D (∗4)
RDEF IG+
1 MJ1
B
Rr E
DEF
Rear
Window Off
1 A Defogger SW
1 M2(A), O1(B)
J31 Rear Window On
Noise Defogger
Filter
(Rear Window E
Defogger)
1 B 1 A (∗1)
1 B (∗2)
1 C (∗6)
1 D (∗4)
W–B
(∗4)
W–B
(∗5)
W–B
(∗5) 7 7
D88
E10 Junction
5 Junction Connector
D40 Connector
B
Junction 5 5
Connector 9 DE1
W–B
(∗5)
11
W–B
W–B
(∗5)
(∗4)
3 5A (LHD)
∗ 1 : Before Jan. 2007 Production
1 5A (RHD) 5 5A
∗ 2 : From Jan. 2007 Production until Jan. 2008 Production
∗ 4 : From Jan. 2009 Production
∗ 5 : Before Jan. 2009 Production
O1 D1 ∗ 6 : From Jan. 2008 Production until Jan. 2009 Production D1
282
YARIS (EM02C4EL)
: Parts Location
Code See Page Code See Page Code See Page
49 (*1) A 62 (*3) 57 (LHD)
D40 J31
61 (*3) 50 (*1) 69 (RHD)
B
53 (*2) E6 62 (*3) 56 (LHD)
D88 M2 A
65 (*4) 50 (*1) 68 (RHD)
C
53 (*2) 62 (*3) 56 (LHD)
D98 D O1 B
65 (*4) 50 (*1) 68 (RHD)
E10
E6 A 50 (*1) 62 (*3)
: Ground Points
Code See Page Ground Points Location
72 (*1)
73 (*2)
D1 Left Kick Panel
78 (*3)
79 (*4)
74 (LHD)
O1 Back Door Panel Right
80 (RHD)
*1: LHD Before Jan. 2009 Production *2: LHD From Jan. 2009 Production *3: RHD Before Jan. 2009 Production
*4: RHD From Jan. 2009 Production
283
YARIS (EM02C4EL)
Cigarette Lighter or Power Outlet
(ACC)
15A
CIG
3 4Q
GR
1
D14
ACC Cigarette Lighter or
Power Outlet
E
2
W–B
5
D40
Junction
Connector
11
W–B
3 5A (LHD)
1 5A (RHD)
D1
284
YARIS (EM02C4EL)
: Parts Location
Code See Page Code See Page Code See Page
48 (*1) D14 64 (*4) 61 (*3)
D40
D14 52 (*2) 49 (*1) 65 (*4)
D40
60 (*3) 53 (*2)
: Ground Points
Code See Page Ground Points Location
72 (*1)
73 (*2)
D1 Left Kick Panel
78 (*3)
79 (*4)
*1: LHD Before Jan. 2009 Production *2: LHD From Jan. 2009 Production *3: RHD Before Jan. 2009 Production
*4: RHD From Jan. 2009 Production
285
YARIS (EM02C4EL)
Audio System
∗ 1 : 6 Speaker
(ACC) (BAT) ∗ 2 : Except 6 Speaker
∗ 3 : Shielded
7. 5A 15A
ACC DOME
2
I4 H4
14 4D 1 Speaker (Rear LH) Speaker (Rear RH)
2 1 2 1
GR
W
R
R
L
8 AD2
D32
R
Y
B
Antenna Amplifier
R
B
B
L
3 A 4 A 8 A 6 B 2 B 3 B 1 B
ACC B ANT RL– RL+ RR– RR+
(∗1)
(∗1)
(∗1)
GR
Y
2 4 2 P4
Tweeter (RH)
Tweeter (LH)
– + – +
W–B
(∗2)
(∗2)
(∗2)
(∗2)
GR
Y
P
D47
D48
TWR– TWR+ TWL– TWL+
1 3 1 3
(∗1)
(∗1)
(∗1)
(∗1)
GR
Y
P
L
2 1 2 1
F6 G6
Speaker (Front Door RH) Speaker (Front Door LH)
D3
286
YARIS (EM02C4EL)
Volume–
Volume+
Seek–
MODE Seek+
D89
Steering Pad SW
Stereo Jack Adapter Assembly
V2(B)
AL0 AR0 ASGN AGND AUX0
GR
BR
W
1 2 3 5 4
9 B 8 B 10 B
D3(C), V2(B)
Spiral Cable
AU2 EAU AU1
5 C 4 C 6 C
(∗3)
(∗3)
W
R
B
BE
LG
P
17 C 15 C 16 C 18 C 19 C 8 C 6 C 7 C
AL1 AR1 ASGN AGND AUX1 SW2 SWG SW1
287
YARIS (EM02C4EL)
Audio System
: Parts Location
Code See Page Code See Page Code See Page
48 (*1) 48 (*1) 56 (LHD)
F6
52 (*2) 52 (*2) 68 (RHD)
D3 C D32
60 (*3) 60 (*3) 56 (LHD)
G6
64 (*4) 64 (*4) 68 (RHD)
48 (*1) 61 (*3) 56 (LHD)
D47 H4
52 (*2) 65 (*4) 68 (RHD)
D10 A
60 (*3) 61 (*3) 56 (LHD)
D48 I4
64 (*4) 65 (*4) 68 (RHD)
48 (*1) 53 (*2) 51 (*1)
D53 C
52 (*2) 65 (*4) 55 (*2)
D11 B V2 B
60 (*3) 53 (*2) 63 (*3)
D89
64 (*4) 65 (*4) 67 (*4)
: Relay Blocks
Code See Page Relay Blocks (Relay Block Location)
1 24 Engine Room R/B (Engine Compartment Left)
: Ground Points
Code See Page Ground Points Location
72 (*1)
Instrument Panel Reinforcement Left
73 (*2)
D3
78 (*3)
Instrument Panel Reinforcement Right
79 (*4)
*1: LHD Before Jan. 2009 Production *2: LHD From Jan. 2009 Production *3: RHD Before Jan. 2009 Production
*4: RHD From Jan. 2009 Production
288
YARIS (EM02C4EL)
Memo
289
YARIS (EM02C4EL)
Combination Meter
10A 7. 5A 7. 5A
ECU–IG ECU–B MET
G
R
2
1
24 4B 16 AA2 (LHD) 30 4B 2 4S 1 4M
L
25 AA2 (RHD)
G
B
L
L
(∗8)
B
2 E 1 E 14 E 16 F (∗12)
D1(A), (C), (E), D2(B), (D), (F) 2 C 1 C 14 C 16 D (∗11)
16 Combination Meter 2 A 1 A 14 A 16 B (∗6)
A37
Junction
Connector
20
Pointer
Dial
Tail
5V IC
Illumination I/F
(∗8)
CPU
B
3 E 24 E (∗12)
3 C 24 C (∗11)
3 A 24 A (∗6)
P P
(∗8) (∗8)
BR
V
11 CA2 11 AD3
W–B 1 4C
(∗8)
(∗8)
P
(∗8)
B
(∗8)
3
P
1 3 2
Gage
IG+ SI SE
W–B
(∗8)
BR
J5
C23 2
Speed Sensor
BE
(∗9)
O
A1 J1 (∗10) D3
290
YARIS (EM02C4EL)
∗ 6 : Before Jan. 2008 Production
∗ 7 : w/ ABS
∗ 8 : w/o ABS
∗ 9 : From Jan. 2009 Production
∗10 : Before Jan. 2009 Production
∗11 : From Jan. 2008 Production until Oct. 2009 Production
∗12 : From Oct. 2009 Production
Electronic Key
Temp. Cool
Temp. Hot
Seat Belt
Driver' s
Door
SRS
ABS
P/S
Display
LED Driver
CPU
Speedometer
Tachometer
I/F I/F
17 E 16 E (∗12)
17 C 16 C (∗11)
17 A 16 A (∗6)
P
SB
(∗8)
(∗7)
P
8 4C
11 AD3
26 4B 8 4D
(∗8)
G
(∗7)
P
20
D36
Junction
Connector
19
(∗8)
R
291
YARIS (EM02C4EL)
Combination Meter
Charge
Oil Pressure
Brake
LED Driver
CPU
CAN Controller
CAN I/F
21 E 20 E 2 F 1 F 12 F (∗12)
21 C 20 C 2 D 1 D 12 D (∗11)
21 A 20 A 2 B 1 B 12 B (∗6)
W
Y
L
18 AD3 19 AD3
Brake Fluid Level
2
Warning SW
(RHD)
(LHD)
(LHD)
V
1
A10
V Y
(RHD) (RHD)
G
P P
(∗7) (∗7)
A1
292
YARIS (EM02C4EL)
P
G
(∗7)
Combination Meter
Check Engine
B
4 F
4 B
4 D
Engine ECU
14 B
14 D
Assembly (Except HID Type ∗3)
H–LP LH/H–LP LO LH
11 B (∗6)
Fuse
11 D (∗11)
11 F (∗12)
(Except HID Type ∗4)
Turn RH
BR
15 F
15 B
15 D
Turn LH
LG
FLASHER Relay (LHD)
8 F
8 B
8 D
Turn Signal Flasher (RHD)
Rear Fog
SB Rear Fog
6 F
6 B
6 D
YARIS (EM02C4EL)
Light Relay
Front Fog
R Front Fog
Light Relay
7 B (∗6)
7 D (∗11)
7 F (∗12)
P
G
(∗7)
293
Combination Meter
SB
W
W
R
Y
W
Parking Brake SW
1
16 5 4 15 11 22
D21
D42 6 17 3 14 7 18
Junction Connector
(RHD)
(RHD)
(∗1)
(∗1)
GR
W
G
V
V
(LHD)
W
(LHD)
27 28 6 14
CANH CANL CANH CANL
D60 D15
Certification ECU DLC3
P P
(∗7) (∗7)
294
YARIS (EM02C4EL)
∗ 1 : w/ Smart Entry & Start System D16
∗ 2 : w/o Smart Entry & Start System Airbag Sensor
Assembly Center
∗ 5 : From Jan. 2008 Production
∗ 6 : Before Jan. 2008 Production
∗ 7 : w/ ABS
∗ 9 : From Jan. 2009 Production
∗10 : Before Jan. 2009 Production
∗12 : From Oct. 2009 Production CANH CANL
∗13 : Before Oct. 2009 Production
13 22
W
B
W
D41
22 11 Junction Connector 8 19
3 14 15 4 1 12
1
E2
(∗7)
(∗7)
C19
W
W
G
L
P
L
W
(LHD) 49 A 41 A 96 B 97 B
CANL CANH ETHW THW
A21(A), C20(B)
Engine ECU
NE+ NE–
122 B 121 B
(∗7)
(∗7)
W
G
(Shielded)
P
L
1
Crankshaft
Position
6 A 5 A (∗13)
Sensor
A15(A), A38(B)
Skid Control ECU with Actuator 25 B 14 B (∗12)
C2
2 CANH CANL
(∗7)
(∗7)
(∗7)
(∗7)
(∗7)
(∗7)
(∗7)
LG
G
R
L
BR
P
Speed Sensors
(∗7)
C1
295
YARIS (EM02C4EL)
Combination Meter
: Parts Location
Code See Page Code See Page Code See Page
46 (LHD) 52 (*2) D31 F 60 (*3)
A10 D1 E
58 (RHD) 64 (*4) 48 (*1)
A
46 (LHD) 48 (*1) 60 (*3)
A15 A B
58 (RHD) 60 (*3) 48 (*1)
D33
46 (LHD) 48 (*1) 52 (*2)
A21 A E
58 (RHD) 52 (*2) 60 (*3)
D2 D
46 (LHD) 60 (*3) 64 (*4)
A37
58 (RHD) 64 (*4) 48 (*1)
46 (LHD) 52 (*2) 52 (*2)
A38 B F D36
58 (RHD) 64 (*4) 60 (*3)
47 (LHD) 48 (*1) 64 (*4)
C2
59 (RHD) 52 (*2) 49 (*1)
D15
47 (LHD) 60 (*3) 53 (*2)
C16 D41
59 (RHD) 64 (*4) 61 (*3)
47 (LHD) 48 (*1) 65 (*4)
C19
59 (RHD) 52 (*2) 49 (*1)
D16
47 (LHD) 60 (*3) 53 (*2)
C20 B D42
59 (RHD) 64 (*4) 61 (*3)
C23 59 (RHD) 48 (*1) 65 (*4)
48 (*1) 52 (*2) 61 (*3)
A D21 D60
60 (*3) 60 (*3) 65 (*4)
48 (*1) 64 (*4) 61 (*3)
D1 D66 D
52 (*2) 48 (*1) 65 (*4)
C B
60 (*3) D31 60 (*3) 57 (LHD)
J5
64 (*4) F 48 (*1) 69 (RHD)
: Relay Blocks
Code See Page Relay Blocks (Relay Block Location)
1 24 Engine Room R/B (Engine Compartment Left)
*1: LHD Before Jan. 2009 Production *2: LHD From Jan. 2009 Production *3: RHD Before Jan. 2009 Production
*4: RHD From Jan. 2009 Production
296
YARIS (EM02C4EL)
: Connector Joining Wire Harness and Wire Harness
Code See Page Joining Wire Harness and Wire Harness (Connector Location)
AD3 79 (*4)
72 (*1)
73 (*2) Engine Room Main Wire and Instrument Panel Wire (Instrument Panel Left)
AD4
78 (*3)
79 (*4)
70 (LHD)
CA1
76 (RHD)
Engine Wire and Engine Room Main Wire (Engine Compartment Left)
70 (LHD)
CA2
76 (RHD)
: Ground Points
Code See Page Ground Points Location
70 (LHD)
A1 Left Suspension Tower
76 (RHD)
70 (LHD)
C1 Engine Block Left
76 (RHD)
72 (*1)
Instrument Panel Reinforcement Left
73 (*2)
D3
78 (*3)
Instrument Panel Reinforcement Right
79 (*4)
74 (LHD)
J1 Right Rear Quarter Panel
80 (RHD)
*1: LHD Before Jan. 2009 Production *2: LHD From Jan. 2009 Production *3: RHD Before Jan. 2009 Production
*4: RHD From Jan. 2009 Production
297
YARIS (EM02C4EL)
Cooling Fan
(BAT) (IG)
∗ 1 : RHD w/ ABS
∗ 2 : LHD, RHD w/o ABS
30A 10A ∗ 3 : From Jan. 2008 Production
RDI ECU–IG ∗ 4 : Before Jan. 2008 Production
∗ 5 : From Jan. 2009 Production
∗ 6 : Before Jan. 2009 Production
2
1 24 4B
B
L
5 A 6 A (∗1)
17 B 18 B (∗2)
LG
B
B
5 1B 6 1B 1 1
2 3
1 5
8 1B 7 1B 1 1 1
(∗6)
BE
E2
LG
W–B
W
L
L
C19
4 AA2 THW
17 AD5 A25(A), A37(B) 2
12 A (∗1)
LG
Junction
Connector 4 B (∗2)
P
2
(∗6)
2
O
22 A 96 B 97 B B
A21(A), C20(B)
M
16 DE1 6 B 5 B (∗2)
A8
L
A14
1 NE+ NE–
1
(∗5)
(∗6)
BE
122 B 121 B
O
W–B
LG
13 AD5
(Shielded)
1 B (∗3 ∗6)
P
L
1 A (∗4 ∗6)
E8(A), (B), D99(C)
1 C (∗5) 2
A/C Amplifier
CFN+
(∗6)
(∗5)
+S
W
1
Pressure SW
Crankshaft
CFN– 2 DE1
Position
2 B (∗3 ∗6)
Sensor
2 A (∗4 ∗6) –S
C2
A3
2 C (∗5) 3 2
W–B
W–B
W
BR
(∗6)
A1 C1 A1
298
YARIS (EM02C4EL)
: Parts Location
Code See Page Code See Page Code See Page
46 (LHD) A25 A 58 (RHD) C20 B 59 (RHD)
A3
58 (RHD) 46 (LHD) 53 (*2)
A37 B D99 C
46 (LHD) 58 (RHD) 65 (*4)
A8
58 (RHD) 47 (LHD) 50 (*1)
C2 A
46 (LHD) 59 (RHD) 62 (*3)
A14 E8
58 (RHD) 47 (LHD) 50 (*1)
C19 B
46 (LHD) 59 (RHD) 62 (*3)
A21 A
58 (RHD) C20 B 47 (LHD)
: Relay Blocks
Code See Page Relay Blocks (Relay Block Location)
1 24 Engine Room R/B (Engine Compartment Left)
: Ground Points
Code See Page Ground Points Location
70 (LHD)
A1 Left Suspension Tower
76 (RHD)
70 (LHD)
C1 Engine Block Left
76 (RHD)
*1: LHD Before Jan. 2009 Production *2: LHD From Jan. 2009 Production *3: RHD Before Jan. 2009 Production
*4: RHD From Jan. 2009 Production
299
YARIS (EM02C4EL)
Air Conditioner (Before Jan. 2009 Production)
(BAT) (IG)
40A 10A
HTR GAUGE
5 2
4 HTR
Relay
L
3 1
1 4L 17 4E 7 4F 5 4Q
(RHD)
(LHD)
B
BR
1 ED1 2 DE2
(RHD)
(LHD)
B
13 DE1
2
M E4
Blower Motor
1
E3
L
Blower Resistor
L 4
W–B
2 3 1
L
G
W–B
BR
B BR
10 6 7 W–B
HI M2 M1 LO E
1 2 4
0 E10
Junction
Connector
1
3 5
2
W–B
R
4
9 DE1
E1 9 5
Blower SW W–B
W–B
5
D40
(RHD)
(LHD)
W–B
W–B
Junction
Connector
R
11
1 DE2 2 ED1
W–B
(RHD)
(LHD)
W–B
W–B
3 5A (LHD)
1 5A (RHD)
D2 D1 D1
300
YARIS (EM02C4EL)
(IG)
7. 5A L
A/C
R
10 4S 29 4B 1 1
LG
O
L
1 5
LG
2 3
1
O
L
MG+
1 1 C8
A/C Compressor
15
LG
LG
O
E10
Junction
Connector
18 6 AE1 16 DE1
E6(A), (B), (C)
Rear Window Defogger SW
LG
O
Y
Volume SW
GR
BR
LG
BR
W–B
14
L 12 E10
Junction
Connector
13
L
E2
A/C Thermistor No. 1
301
YARIS (EM02C4EL)
Air Conditioner (Before Jan. 2009 Production)
∗ 3 : RHD w/ ABS
∗ 4 : LHD, RHD w/o ABS
∗ 5 : From Jan. 2008 Production
∗ 6 : Before Jan. 2008 Production
R
21 AA2 20 AA2
R
8 AD5 9 AD5
R
GR
W
R
B
GR
W
R
17 B 19 B 12 B 2 B (∗5)
17 A 19 A 12 A 2 A (∗6) 13 AD5 3 AE1 18 A 30 A
AC1 ACT PSW CFN– ACT AC1
A21(A), C20(B)
Engine ECU
NE+ NE–
122 B 121 B
GR
W
E8(A), (B)
A/C Amplifier
12 A 13 A 14 A (∗3) (Shielded)
4 B 6 B 5 B (∗4)
P
L
A25(A), A37(B) 2 4
Junction +S CUT+
Connector
Pressure SW
Crankshaft Position
1
A3
Sensor
–S CUT–
C2
3 1 2
W–B
W–B
W–B
BR
A1 C1
302
YARIS (EM02C4EL)
: Parts Location
Code See Page Code See Page Code See Page
46 (LHD) C20 B 59 (RHD) A 62 (*3)
A3
58 (RHD) 49 (*1) 50 (*1)
D40 B
46 (LHD) 61 (*3) E6 62 (*3)
A21 A
58 (RHD) 50 (*1) 50 (*1)
E1 C
A25 A 58 (RHD) 62 (*3) 62 (*3)
46 (LHD) 50 (*1) 50 (*1)
A37 B E2 A
58 (RHD) 62 (*3) 62 (*3)
E8
47 (LHD) 50 (*1) 50 (*1)
C2 E3 B
59 (RHD) 62 (*3) 62 (*3)
47 (LHD) 50 (*1) 50 (*1)
C8 E4 E10
59 (RHD) 62 (*3) 62 (*3)
C20 B 47 (LHD) E6 A 50 (*1)
: Relay Blocks
Code See Page Relay Blocks (Relay Block Location)
1 24 Engine Room R/B (Engine Compartment Left)
: Ground Points
Code See Page Ground Points Location
70 (LHD)
A1 Left Suspension Tower
76 (RHD)
C1 70 (LHD) Engine Block Left
*1: LHD Before Jan. 2009 Production *2: LHD From Jan. 2009 Production *3: RHD Before Jan. 2009 Production
*4: RHD From Jan. 2009 Production
303
YARIS (EM02C4EL)
Air Conditioner (Before Jan. 2009 Production)
: Ground Points
Code See Page Ground Points Location
C1 76 (RHD) Engine Block Left
72 (*1)
D1 Left Kick Panel
78 (*3)
72 (*1)
D2 Right Kick Panel
78 (*3)
*1: LHD Before Jan. 2009 Production *2: LHD From Jan. 2009 Production *3: RHD Before Jan. 2009 Production
*4: RHD From Jan. 2009 Production
304
YARIS (EM02C4EL)
Memo
305
YARIS (EM02C4EL)
Air Conditioner (From Jan. 2009 Production)
(BAT) (IG)
40A 10A
HTR GAUGE
5 2
4 HTR
Relay
L
3 1
1 4L 17 4E 7 4F 5 4Q
BR
B
M D96
Blower Motor
1
D95
L
Blower Resistor
L 4
W–B
2 3 1
L
G
W–B
BR
B BR
10 6 7 W–B
HI M2 M1 LO E
1 2 4
0 D88
Junction
Connector
1
3 5
2
3
W–B
4
R
D93 9 5
Blower SW W–B
R
W–B
W–B
5 5A
D2 D1 D2 D1
306
YARIS (EM02C4EL)
(IG)
7. 5A L
A/C
R
10 4S 29 4B 1 1
LG
L
1 5
7 CA1
HTR SUB1
/AC MG
11 AA2 Relay
BE
LG
FAN NO. 1 Relay
2 3
1
L
MG+
1 1 C8
A/C Compressor
LG
LG
15
D88
Junction
Connector 6 AD6
D98 18
Rear Window Defogger SW
BE
LG
Y
Volume SW
D99
14 15 1 A/C Amplifier
IG+ MGC CFN+
GR
BR
LG
BR
W–B
14
L 12 D88
Junction
Connector
13
L
D94
A/C Thermistor No. 1
307
YARIS (EM02C4EL)
Air Conditioner (From Jan. 2009 Production)
∗ 3 : RHD w/ ABS
∗ 4 : LHD, RHD w/o ABS
R
21 AA2 20 AA2
R
8 AD5 9 AD5
GR
GR
W
W
R
R
B
B
FAN NO. 2 Relay
17 19 12 2 13 AD5 3 AD6 18 A 30 A
AC1 ACT PSW CFN– ACT AC1
A21(A), C20(B)
Engine ECU
NE+ NE–
122 B 121 B
GR
W
D99
A/C Amplifier
12 A 13 A 14 A (∗3) (Shielded)
4 B 6 B 5 B (∗4)
P
L
A25(A), A37(B) 2 4
Junction +S CUT+
Connector
Pressure SW
Crankshaft Position
1
A3
Sensor
–S CUT–
C2
3 1 2
W–B
W–B
W–B
BR
A1 C1
308
YARIS (EM02C4EL)
: Parts Location
Code See Page Code See Page Code See Page
46 (LHD) 47 (LHD) D94 65 (*4)
A3 C8
58 (RHD) 59 (RHD) 53 (*2)
D95
46 (LHD) 47 (LHD) 65 (*4)
A21 A C20 B
58 (RHD) 59 (RHD) 53 (*2)
D96
A25 A 58 (RHD) 53 (*2) 65 (*4)
D88
46 (LHD) 65 (*4) 53 (*2)
A37 B D98
58 (RHD) 53 (*2) 65 (*4)
D93
47 (LHD) 65 (*4) 53 (*2)
C2 D99
59 (RHD) D94 53 (*2) 65 (*4)
: Relay Blocks
Code See Page Relay Blocks (Relay Block Location)
1 24 Engine Room R/B (Engine Compartment Left)
: Ground Points
Code See Page Ground Points Location
70 (LHD)
A1 Left Suspension Tower
76 (RHD)
70 (LHD)
C1 Engine Block Left
76 (RHD)
73 (*2)
D1 Left Kick Panel
79 (*4)
73 (*2)
D2 Right Kick Panel
79 (*4)
*1: LHD Before Jan. 2009 Production *2: LHD From Jan. 2009 Production *3: RHD Before Jan. 2009 Production
*4: RHD From Jan. 2009 Production
309
YARIS (EM02C4EL)
I GROUND POINT
W–B
A15 (GND2)
Skid Control (∗8) W–B
(PGND) A19
ECU with Actuator Power Steering
ECU
W–B
(GND1)
(∗8) A3
W–B
A38 (GND2)
Skid Control (∗9)
ECU with Actuator
W–B
W–B
(GND1)
(∗9)
A2
W–B
23 13
W–B W–B
AA2 CA2 (SE) C23
(w/o ABS) (w/o ABS) Speed Sensor
(w/o ABS)
W–B
W–B
A21 (EC)
Engine ECU
3
W–B W–B W–B
A30 (E) 1A EFI Relay
Wireless Door Lock
Buzzer
3
W–B
1B IG2 Relay
W–B
W–B W–B
2 (–S) H–LP/AMT
Relay
W–B A1 W–B
A33 (GND) (E) A10
W–B
W–B W–B
A34 (L) (L) A14
Security Horn Radiator Fan
Resistor
W–B
W–B W–B
A2 (E) (GND) A36
Turn Signal Lamp Option Connector
(Front Side LH)
W–B
W–B W–B
A1 (E) (E) A9
Turn Signal Lamp Windshield Wiper
(Front Side RH) Motor
W–B
W–B W–B
A3 (CUT–) 1 (E) FAN NO. 2
Pressure SW Relay
W–B
W–B W–B
(–S)
W–B
W–B
ST Relay (–S) 1
8
W–B W–B
BA1
6
W–B W–B
BA1
(HID Type) (HID Type)
310
YARIS (EM02C4EL)
I
(Shielded)
W–B
(GND) C14
Ignition Coil
(No. 4)
W–B W–B
(GND) C11
Ignition Coil
(No. 1)
BR
B
W–B
(GND) C12
Ignition
Coil (No. 2)
W–B
(GND) C13
Ignition Coil
C1 (No. 3)
W
C20 (E03)
Engine ECU
BR
(ME01)
BR
(E01)
W
(E1)
C2
W–B
(E) B23
(RHD ∗6 Except HID Type) Clearance
W–B Lamp (RH)
B16 (HI)
Headlamp Assembly (HID Type)
(RH) W–B
(E) B21
(RHD ∗6 Except HID Type) Clearance
W–B Lamp (LH)
B17 (HI)
Headlamp Assembly (HID Type)
(LH) W–B
(E) B22
(LHD ∗6 Except HID Type) Clearance
W–B Lamp (RH)
B1 (E)
Turn Signal Lamp
(Front RH) W–B
(E) B20
(LHD ∗6 Except HID Type)
W–B
Clearance
(∗6)
W–B
(RH E) B14
Headlamp Leveling
Motor (RH)
(E) B3
(HID Type) (HID Type) (∗7 Except HID Type) Clearance
Lamp (RH)
B1
311
YARIS (EM02C4EL)
I GROUND POINT
W 9 10 W
(ILL–) D98
(∗6) (∗6) Rear Window
Defogger SW
8 W
(ILL–) D97
(∗6) A/C SW
D88
Junction Connector
8
W W R 9 10 W
D7 (ILL–) DE1 (ILL–) E6
Hazard Warning (∗7) (∗7) (∗7) Rear Window
Signal SW Defogger SW
W
W 8 W
D20 (ILL–) (ILL–) E5
A/T Shift Lever (∗7) A/C SW
Illumination E10
19 B 20 B Junction Connector
7 W–B
(E) D98
(∗6) Rear Window
15 A D36(A), D37(B) Defogger SW
Junction Connector
W–B 5 4 W–B
W–B
W–B
(∗6)
W–B
D73 (–S)
ACC Relay W–B
W–B
W–B (∗4)
D65 (GND2)
Main Body ECU (∗1)
5 5A W–B
W–B
(∗5)
W–B
D56 (SGND) 1
Steering Lock ECU (∗1) 5A
W–B
D67 (–ST) 4
ST Cut Relay (∗1) W–B
5A
(∗5)
W–B
W–B
D60 (E) 6
Certification ECU (∗1) W–B
5B (E) G8
Power Window
Regulator Motor
W–B (Front LH)
D95 (E)
Blower Resistor (∗6) 1
W–B
5B (E) G5
Door Lock
W–B Assembly
E1 (E) (Front LH)
Blower SW (∗7)
(∗4 ∗7)
W–B
W–B
3
(∗5 ∗7) W–B
5B (E) G1
W–B
W–B
4
(∗5 ∗7)
(∗4 ∗7)
W–B W–B
W–B
W–B
W–B
D15 (CG) 3
DLC3 W–B
5A
W–B
(∗4)
1
W–B W–B W–B
D55 (COM) 5A
W–B
D1
W–B
(GND) W–B
(∗4)
W–B
312
YARIS (EM02C4EL)
I
W–B 4 7 W–B
E8 (GND) (E) E6
A/C Amplifier Rear Window
Defogger SW
E10
Junction
Connector
5 ∗ 1 : w/ Smart Entry & Start System
∗ 2 : w/o Smart Entry & Start System
W–B
∗ 4 : LHD
∗ 5 : RHD
∗ 6 : From Jan. 2009 Production
∗ 7 : Before Jan. 2009 Production
9 DE1
W–B W–B
W–B
D7 (E) (LFG) D4
Hazard Warning Headlamp Dimmer
Signal SW SW Assembly
W–B
W–B W–B
(∗4) (∗4)
W–B W–B
(∗5) (∗5)
5
W–B 10 12 W–B
D74 (E) (E) D22
Theft Warning ECU Shift Lock
11 D40 Control ECU
Junction
B Connector
O1 (E)
Rear Window
Defogger
O1
W–B
W–B
W–B
(∗4)
(∗5)
D10 (GND)
Radio Receiver
Assembly
BR
D1 (ET)
Combination Meter
D3
W–B
(∗4)
W–B
(∗5)
W–B W–B
(∗4) (∗4)
W–B W–B
313
YARIS (EM02C4EL)
I GROUND POINT
12
W–B W–B W–B
I3 (E) IJ1 (E) J34
Door Lock Assembly Front Seat
(Rear LH) Inner Belt (RH)
12
W–B W–B W–B
H3 (E) HJ1 (E) J35
Door Lock Assembly Front Seat
(Rear RH) Inner Belt (LH)
W–B
W–B
17 JD1
W–B
(∗4) 15 4A
7 1
W–B W–B
4M 4S
(∗5)
7
W–B
D71 (E) 4R
Turn Signal Flasher
28
W–B
D4 (E) 4E (GND)
Headlamp Dimmer (∗4) FLASHER Relay
SW Assembly
12
W–B
(ED) 4E (GND1)
Main Body ECU
2
W–B
D5 (EW) 4E
Windshield Wiper SW HTR Relay
Assembly
30
W–B
D16 (E1) 4E
Airbag Sensor IG 1 Relay
Assembly Center
14
W–B
(E2) 4E
Noise Filter
1
W–B W–B
K2 (E) 4K
Room Lamp (Center) PWR Relay
W–B 17 4E
K1 (L)
Map Lamp
W–B
W–B
W–B W–B
(∗4) (∗4)
W–B W–B
314
YARIS (EM02C4EL)
I
W–B
(LSWE) N7
Back Door
Lock Assembly
W–B
(ACT–) N2
Back Door Lock
Assembly
W–B
∗ 1 : w/ Smart Entry & Start System (E)
∗ 2 : w/o Smart Entry & Start System
∗ 4 : LHD
∗ 5 : RHD W–B W–B W–B
(L) N6
Luggage
Electrical
W–B Key SW
(E)
N1
8 MN1
W–B
J38 (E)
B
License Plate Lamp
W–B
(GND) J13
7 MJ1 Door Control
Receiver
W–B W–B
J5 (E) W–B (E) J4
Fuel Suction Rear Combination
Pump and Lamp (LH)
Gage Assembly
11
BR W–B W–B
(FE) MJ1 (E) M1
Center Stop Lamp
W–B
W–B
J3 (E)
Rear Combination W–B
Lamp (RH)
J1 J2
8 2 6
BR W–B W–B
R2 (GND) FR1 6B 6A (GND) D58
Electrical Key ID Code Box
Oscillator (Front Door RH)
4 5 5
W–B W–B
D12 (E) 6A 6A 6B (E) F8
Outer Mirror SW (∗4) (∗5) Power Window
Regulator Motor
(Front RH)
1 3 1
W–B W–B
D19 (UN–) 6A 6A 6B (E) F5
Unlock Warning SW (∗2) Door Lock
(∗4) (∗5) Assembly
(Front RH)
W–B
D56 (GND)
Steering Lock ECU (∗1)
3 4
W–B W–B
F7 (E) 6B 6B (GND) F9
Power Window Master SW Outer Rear View
Mirror (RH)
4
W–B
D4 (T1) 6A
Headlamp Dimmer (∗5)
SW Assembly
W–B
(∗4)
W–B
W–B
(∗4)
W–B
D2
315
YARIS (EM02C4EL)
I GROUND POINT
: Parts Location
Code See Page Code See Page Code See Page
48 (*1) 60 (*3) 53 (*2)
D37 B D88
52 (*2) 64 (*4) 65 (*4)
D36 A
60 (*3) 49 (*1) 50 (*1)
E10
64 (*4) 53 (*2) 62 (*3)
D40
48 (*1) 61 (*3)
D37 B
52 (*2) 65 (*4)
: Relay Blocks
Code See Page Relay Blocks (Relay Block Location)
1 24 Engine Room R/B (Engine Compartment Left)
2 28 Engine Room R/B No.2 (Engine Compartment Right)
*1: LHD Before Jan. 2009 Production *2: LHD From Jan. 2009 Production *3: RHD Before Jan. 2009 Production
*4: RHD From Jan. 2009 Production
316
YARIS (EM02C4EL)
I
: Connector Joining Wire Harness and Wire Harness
Code See Page Joining Wire Harness and Wire Harness (Connector Location)
IJ1 80 (RHD) Rear Door No.2 Wire and Floor Wire (Left Center Pillar)
72 (*1)
73 (*2)
JD1 Floor Wire and Instrument Panel Wire (Instrument Panel Left)
78 (*3)
79 (*4)
74 (LHD)
MJ1 Back Door No.1 Wire and Floor Wire (Left Rear Quarter Panel)
80 (RHD)
74 (LHD)
MN1 Back Door No.1 Wire and Back Door No.2 Wire (Back Door Panel Center)
80 (RHD)
: Ground Points
Code See Page Ground Points Location
70 (LHD)
A1
76 (RHD)
Left Suspension Tower
70 (LHD)
A2
76 (RHD)
72 (*1)
Left Cowl Top Side Panel
73 (*2)
A3
78 (*3)
Right Cowl Top Side Panel
79 (*4)
70 (LHD)
B1 Radiator Support Left
76 (RHD)
70 (LHD)
C1
76 (RHD)
Engine Block Left
70 (LHD)
C2
76 (RHD)
72 (*1)
73 (*2)
D1 Left Kick Panel
78 (*3)
79 (*4)
72 (*1)
73 (*2)
D2 Right Kick Panel
78 (*3)
79 (*4)
72 (*1)
Instrument Panel Reinforcement Left
73 (*2)
D3
78 (*3)
Instrument Panel Reinforcement Right
79 (*4)
74 (LHD)
J1 Right Rear Quarter Panel
80 (RHD)
74 (LHD)
J2 Left Rear Quarter Panel
80 (RHD)
74 (LHD)
N1 Back Door Panel Center
80 (RHD)
74 (LHD)
O1 Back Door Panel Right
80 (RHD)
*1: LHD Before Jan. 2009 Production *2: LHD From Jan. 2009 Production *3: RHD Before Jan. 2009 Production
*4: RHD From Jan. 2009 Production
317
YARIS (EM02C4EL)
J POWER SOURCE (Current Flow Chart)
The chart below shows the route by which current flows from the battery to each electrical source
(Fusible Link, Circuit Breaker, Fuse, etc.) and other Parts.
DEF Relay
30A DEF 2 (Point Side) 2
30A ABS2/VSC2
30A RDI
7.5A RR FOG
10A STOP
2
15A FR FOG (*6) (*6)
Headlamp Dimmer
SW Assembly D4
20A D DOOR
(*1)
25A D/L
IG 1 Relay
(Point Side) 2
20A RL DOOR
PWR Relay
(Point Side) 2 20A RR DOOR 2
30A POWER
10A HORN
1
20A EFI
7.5A ALT-S
10A
(*4) H-LP LH/H-LP LO LH 7.5A ECU-B
1
10A
H-LP RH/H-LP LO RH 10A ETCS
10A HAZ 1
15A DOME
20A S-LOCK
30A ST
318
YARIS (EM02C4EL)
J
Example
Starter S1
10A ID/UP 2 Parts Code or Location
7.5A DRL 4
Location
Electrical Source
(*6) (*6)
7.5A PANEL2 2 7.5A PANEL1 2
7.5A A/C
10A ECU-IG
10A GAUGE
2
15A RR WIP
15A WSH
15A
20A WIP (*3) H-LP LO LH
1
15A
H-LP LO RH
7.5A IGN
IG2 Relay
(Point Side) 1 2
7.5A MET
[LOCATION]
1 : Engine Room R/B and Engine Room J/B (See Page 24)
2 : Instrument Panel J/B (See Page 30)
3 : Fusible Link Block (See Page 42)
4 : Fuse Block (See Page 44)
5 : Engine Room R/B No.7 (See Page 29)
319
YARIS (EM02C4EL)
J POWER SOURCE (Current Flow Chart)
Engine Room R/B and Engine Room J/B (See Page 24)
Fuse System Page
7.5A ALT-S Charging 108
Combination Meter 290
Door Lock Control (LHD) 230
Door Lock Control (RHD) 236
ECT and A/T Indicator 132
Engine Control 114
Engine Immobiliser System (w/o Smart Entry & Start System) 128
Interior Light 166
Key Reminder (w/o Smart Entry & Start System) 192
7.5A ECU-B
Light Reminder 194
Power Window (LHD) 222
Power Window (RHD) 226
Smart Entry & Start System 92
Theft Deterrent (LHD) 254
Theft Deterrent (RHD) 262
Wireless Door Lock Control (LHD) 242
Wireless Door Lock Control (RHD w/o Smart Entry & Start System) 248
ECT and A/T Indicator 132
10A ETCS
Engine Control 114
Turn Signal and Hazard Warning Light (LHD) 158
10A HAZ
Turn Signal and Hazard Warning Light (RHD) 162
Headlight (Except HID Type) 150
10A H-LP LH/H-LP LO LH Theft Deterrent (LHD) 254
Theft Deterrent (RHD) 262
10A H-LP RH/H-LP LO RH Headlight (Except HID Type) 150
Horn 190
10A HORN Theft Deterrent (LHD) 254
Theft Deterrent (RHD) 262
Door Lock Control (RHD) 236
ECT and A/T Indicator 132
Engine Control 114
Ignition 110
Interior Light 166
15A AM2
Light Reminder 194
Power Window (RHD) 226
Smart Entry & Start System 92
Starting (w/o Smart Entry & Start System) 106
Theft Deterrent (RHD) 262
* These are the page numbers of the first page on which the related system is shown.
320
YARIS (EM02C4EL)
J
Fuse System Page
Audio System 286
Interior Light 166
Smart Entry & Start System 92
Starting (w/o Smart Entry & Start System) 106
15A DOME
Theft Deterrent (LHD) 254
Theft Deterrent (RHD) 262
Wireless Door Lock Control (LHD) 242
Wireless Door Lock Control (RHD w/o Smart Entry & Start System) 248
15A H-LP LO LH Headlight (HID Type) 146
15A H-LP LO RH Headlight (HID Type) 146
20A EFI Engine Control 114
20A S-LOCK Smart Entry & Start System 92
ABS (Before Oct. 2009 Production) 198
30A ABS2/VSC2
ABS (From Oct. 2009 Production) 204
Headlight (HID Type) 146
30A H-LP MAIN
Theft Deterrent (RHD) 262
30A RDI Cooling Fan 298
Smart Entry & Start System 92
30A ST
Starting (w/o Smart Entry & Start System) 106
Air Conditioner (Before Jan. 2009 Production) 300
40A HTR
Air Conditioner (From Jan. 2009 Production) 306
ABS (Before Oct. 2009 Production) 198
50A ABS1/VSC1
ABS (From Oct. 2009 Production) 204
50A EPS EPS 216
321
YARIS (EM02C4EL)
J POWER SOURCE (Current Flow Chart)
Fuse System Page
7.5A ACC Wireless Door Lock Control (RHD w/o Smart Entry & Start System) 248
ECT and A/T Indicator 132
Engine Control 114
7.5A IGN Engine Immobiliser System (w/o Smart Entry & Start System) 128
Smart Entry & Start System 92
SRS 209
ABS (Before Oct. 2009 Production) 198
ABS (From Oct. 2009 Production) 204
Charging 108
Combination Meter 290
ECT and A/T Indicator 132
7.5A MET Engine Control 114
EPS 216
Key Reminder (w/o Smart Entry & Start System) 192
Light Reminder 194
Seat Belt Warning 214
SRS 209
7.5A OBD2 DLC3 140
Front Fog Light 182
Light Reminder 194
7.5A PANEL1
Rear Fog Light 186
Taillight and Illumination 172
Front Fog Light 182
Light Reminder 194
7.5A PANEL2
Rear Fog Light 186
Taillight and Illumination 172
7.5A RR FOG Rear Fog Light 186
ABS (Before Oct. 2009 Production) 198
ABS (From Oct. 2009 Production) 204
Combination Meter 290
Cooling Fan 298
Door Lock Control (LHD) 230
Door Lock Control (RHD) 236
10A ECU-IG
ECT and A/T Indicator 132
Engine Control 114
EPS 216
Light Reminder 194
Power Window (LHD) 222
Power Window (RHD) 226
* These are the page numbers of the first page on which the related system is shown.
322
YARIS (EM02C4EL)
J
Fuse System Page
Smart Entry & Start System 92
Theft Deterrent (LHD) 254
10A ECU-IG Theft Deterrent (RHD) 262
Wireless Door Lock Control (LHD) 242
Wireless Door Lock Control (RHD w/o Smart Entry & Start System) 248
ABS (Before Oct. 2009 Production) 198
ABS (From Oct. 2009 Production) 204
Air Conditioner (Before Jan. 2009 Production) 300
Air Conditioner (From Jan. 2009 Production) 306
Back-Up Light 178
10A GAUGE Charging 108
ECT and A/T Indicator 132
Rear Window Defogger 282
Shift Lock 276
Turn Signal and Hazard Warning Light (LHD) 158
Turn Signal and Hazard Warning Light (RHD) 162
10A ID/UP Engine Control 114
ABS (Before Oct. 2009 Production) 198
ABS (From Oct. 2009 Production) 204
ECT and A/T Indicator 132
10A STOP Engine Control 114
Shift Lock 276
Smart Entry & Start System 92
Stop Light 180
Engine Control 114
Front Fog Light 182
Headlight Beam Level Control 154
10A TAIL
Light Reminder 194
Rear Fog Light 186
Taillight and Illumination 172
15A CIG Cigarette Lighter or Power Outlet 284
Front Fog Light 182
15A FR FOG
Rear Fog Light 186
15A RR WIP Rear Wiper and Washer 274
Front Wiper and Washer 270
15A WSH
Rear Wiper and Washer 274
Power Window (LHD) 222
20A D DOOR
Power Window (RHD) 226
20A RL DOOR Power Window (LHD) 222
* These are the page numbers of the first page on which the related system is shown.
323
YARIS (EM02C4EL)
J POWER SOURCE (Current Flow Chart)
Fuse System Page
20A RL DOOR Power Window (RHD) 226
Power Window (LHD) 222
20A RR DOOR
Power Window (RHD) 226
20A WIP Front Wiper and Washer 270
Door Lock Control (LHD) 230
Door Lock Control (RHD) 236
Interior Light 166
Light Reminder 194
25A D/L Smart Entry & Start System 92
Theft Deterrent (LHD) 254
Theft Deterrent (RHD) 262
Wireless Door Lock Control (LHD) 242
Wireless Door Lock Control (RHD w/o Smart Entry & Start System) 248
Engine Control 114
30A DEF
Rear Window Defogger 282
Power Window (LHD) 222
30A POWER
Power Window (RHD) 226
* These are the page numbers of the first page on which the related system is shown.
324
YARIS (EM02C4EL)
Memo
325
YARIS (EM02C4EL)
K CONNECTOR LIST
A1 A2 A3 A4 A5
Gray Gray Dark Gray Gray Black
1 2 1 2 1
2 3 1 2 1 2
4
A6 A7 A8 A9 A10 A11
Yellow Gray Gray
1 2 1 2 1 2 1 2
1 2 3
1 2 4 5
1 2 1 2
1 2
3 4
3 4 5 6 7 8 9 10 11 12
1 2
13 14 15 16 17 18 19 20 21 22
23 24
25 26 27 28 29 30 31 32 33 34
1 2 1 2 3 4 5 6
1 1
2 2
326
YARIS (EM02C4EL)
K
A21 A24
Black
1 2 3 4 5 6 7 8 9 10 11
1 2 3 4 5 6
12 13 14 15 16 17 18 19
7 8 9 10 11 12
20 21 22 23 24 25 26 27 28 29 30
31 32 33 34 35 36 37 38 39 40 41
42 43 44 45 46 47 48 49
50 51 52 53 54 55 56 57 58 59 60
1 2 3 4 1 2
1 2 3 4 5 6 7 8 9 10 11
12 13 14 15 16 17 18 19 20 21 22
1 2 1 2
1 2 1 2
1 2
3 4
1
A37
1 2 3 4 5 6 7 8 9 10 11
12 13 14 15 16 17 18 19 20 21 22
327
YARIS (EM02C4EL)
K CONNECTOR LIST
A38 B1 B1
Gray (*3) (HID Type) Gray
1 2
1 2
1 2 3 4 5 6 7 8 9 10 11 12
13 14 15 16 17 18 19 20 21 22 23 24
25 26 27 28 29 30 31 32 33 34
B2 B3 B4 B6 B7
Black Brown Brown
1
1 1
2 3 2 3
1 2 1 2
B8 B8 B9 B10
(*3) (HID Type) Gray Black Black
1 2
1 2 1 2 1 2
1 2 3 1 2 3
1 2
3 4
1 2 3 4 5 6
7 8 9 10 11 12
1 2 1 2
1 2 1 2 1 2
3 4
328
YARIS (EM02C4EL)
K
B22 B23 B24 B25 C1
Brown Black Gray Gray
1
1 2
1 2 1 2 1 2
C2 C3 C4 C5 C6
Black Blue Black Gray Black
1 2 1 2 1 2
1 2 1 2
C7 C8 C9 C10 C11
Gray Gray Black Black
1
1 2 1
1 2 1 2 3 4
3 4
1 2 3 4 1 2 3 4 1 2 3 4
1
1
1 2
1 2 3 4 5 6 1 2
329
YARIS (EM02C4EL)
K CONNECTOR LIST
C20 C22
Black Gray
1 2
X X X X X X X X X X X X X X X X X X X X X X X
X X X X X X X X X X X X X X 38 39 40
47 48 49 50 51 52 53 54 55 56 57 58 59 60 61 62 63 41 42 43 44 45 46
64 65 66 67 68 69 70 71 72 73 74 75 76 77 78 79 80 81 82 83 84 85 86
87 88 89 90 91 92 93 94 95 96 97 98 99 100 101 102 103
110 111 112 113 114 115 116 117 118 119 120 121 122 123 124 125 126 104 105 106 107 108 109
1 2 3 1 2 1 2 3 4 5
1 2 1 2 3 4
5 6 7 8 9
1
1 2
1 2 3 4 5 1 2 3 4 1
6 7 8 9 10
D1 D1 D1
(*4) (*5) (*6) Black
1 2 3 4 5 6 7 8 9 10 11 12 1 2 3 4 5 6 7 8 9 10 11 12 1 2 3 4 5 6 7 8 9 10 11 12
13 14 15 16 17 18 19 20 21 22 23 24 13 14 15 16 17 18 19 20 21 22 23 24 13 14 15 16 17 18 19 20 21 22 23 24
D2 D2 D2 D3
(*4) (*5) (*6) Black (*4)
1 2 3 4 5 6 7 8 1 2 3 4 5 6 7 8 1 2 3 4 5 6 7 8 1 2 3 4 5 6
9 10 11 12 13 14 15 16 9 10 11 12 13 14 15 16 9 10 11 12 13 14 15 16 7 8 9 10 11 12
330
YARIS (EM02C4EL)
K
D3 D4 D5 D6 D7
(*7) Gray
1 2 3 4
5 6 7 8 9 10 11 12 13 1 2 3 1 2 3 4
1 2 3 4 5 6 1 2 3 4
7 8 9 10 11 12 4 7 5 10
5 6 6 7 8 9
1 2 3 4 1 2
1 2
5 6 7 8 9 10 3 4 5 6
1 2 3 4 1 2 3 4 5 6 7 8 9 10
5 6 7 8
1 2 3 4 5 6 7 8 9 10
1 2
11 12 13 14 15 16 17 18 19 20
16 15 14 13 12 11 10 9
8 7 6 5 4 3 2 1 21 22 23 24 25 26 27 28 29 30
1 2 1 2 1
1 2 3 4 1 2 3 4 5 6
1 2 3 4 5 6
7 8 9 10 11 12
7 8 9 10 11 12
1 2
1 2
1 2 3 4 5 3 4 3 4
1 2 3 4 5 6 7
6 7 8 9 10 11 12 13 14 15 16 5 6
331
YARIS (EM02C4EL)
K CONNECTOR LIST
D31 D31 D32 D33
(*4) (*7) (*4)
1 2 3 4 5 6 1 2 3 4 5 6 1 2 3 10 11 12
4 5 6 7 8 9
7 8 9 10 11 12 7 8 9 10 11 12
13 14 15 16 17 18 19 20 21 22 23 24 25 26
D33 D34
(*7)
1 2 3 10 11 12
4 5 6 7 8 9
1 2 3 4 5 6 7 8 9 10 11
13 14 15 16 17 18 19 20 21 22 23 24 25 26
12 13 14 15 16 17 18 19 20 21 22
D35
1 2 3 4 5 6 7 8 9 10 11
12 13 14 15 16 17 18 19 20 21 22
D36
1 2 3 4 5 6 7 8 9 10 11
12 13 14 15 16 17 18 19 20 21 22
D37
1 2 3 4 5 6 7 8 9 10 11
12 13 14 15 16 17 18 19 20 21 22
332
YARIS (EM02C4EL)
K
D38
1 2 3 4 5 6 7 8 9 10 11
12 13 14 15 16 17 18 19 20 21 22
D39
1 2 3 4 5 6 7 8 9 10 11
12 13 14 15 16 17 18 19 20 21 22
D40
1 2 3 4 5
6 7 8 9 10 11 12 13
D41
1 2 3 4 5 6 7 8 9 10 11
12 13 14 15 16 17 18 19 20 21 22
1 2
1 2 3 4
1 2 3 4 5 6 7 8 9 10 11
12 13 14 15 16 17 18 19 20 21 22
333
YARIS (EM02C4EL)
K CONNECTOR LIST
D45 D45 D46 D47 D48
(*8) Gray (*9)
3 3 3 1 2 3 4 1 2 3 4
5 5 5
1 4 2 1 4 2 1 2
1 2 3 4
1 2 3 4 5 6 7 8 9 10 1 2 3 4 5 6 7 1 2 3 4 5 6 7
11 12 13 14 15 16 17 18 19 20 8 9 10 11 12 13 14
D58 D58
(*4) (*7)
1 2 3 4 5 6 7 8 1 2 3 4 5 6 7 8
1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17
18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 1 2 3 1 2 3
1 2 3 4 5 6 7
1 2 3 4 5 6 1 2 3 4 5 6
1 4
2 3 8 9 10 11 12 13 14
7 8 9 10 11 12 13 14 15 16 17 7 8 9 10 11 12 13 14 15 16 17 5 6 7 8 9 10 15 16 17 18 19
18 19 20 21 22 23 24 25 26 18 19 20 21 22 23 24 25 26 11 12 13 14 15 16
1 2 3
3 3 3
4 5 6 7 8
5 5 5
1 2 1 2 1 2
334
YARIS (EM02C4EL)
K
D74
1 2 3 4 5 6 7 8 9 10 11 12 13 14 15
16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36
1 5
2 3 4
1 2 3 4 5 6 7 8 9 10 11 1 2 3 4 6 7 8 9 10
5 6 7 8
12 13 14 15 16 17 18 19 20 21 22
1 2
1 2
1 2
1 2 3 4 5 6 7 8
1 2 3 4 5 6 7 8
3 4
D99 E1 E2 E3 E4
Black Black
1 2
1 5 1 2
2 3 4 1 2
1 2 3 4 5 6 7 8 9 10 11 12 13 14
6 7 8 9 10 3 4
15 16 17 18 19 20 21 22 23 24 25 26 27 28
E5 E6 E6 E6
(*10) (*11) Black (*7) Black
1 2 3 4 5 6 7 8 1 2 3 4 5 6 7 8 1 2 3 4 5 6 7 8
1 2 3 4 5 6 7 8
E8 E8
(*4) (*7)
1 2 3 4 5 6 7 8 9 10 11 12 13 14 1 2 3 4 5 6 7 8 9 10 11 12 13 14
15 16 17 18 19 20 21 22 23 24 25 26 27 28 15 16 17 18 19 20 21 22 23 24 25 26 27 28
335
YARIS (EM02C4EL)
K CONNECTOR LIST
E10 F1 F2
1 2 3 4 5 2 1 3
1 2 3 4 5 6 7 8 9 10 11 5 4
12 13 14 15 16 17 18 19 20 21 22
F4 F5 F6 F7 F8
1 2
1 2 3 4 1
3 4 5 6
1 2 3 4 5 6 7 8 9 1 2
5 6 7 8 9 10 2
10 11 12 13 14 15 16 17 18
3 4 5 6
7 8 9 10
F9 G1 G2 G4
1 2
5 4 3 2 1 2 1 3 3 4 5 6
1 2 3 4 5 6 7 8 9
10 9 8 7 6 5 4
10 11 12 13 14 15 16 17 18
G5 G6 G7 G8 G9
1 2 3 4 1 1 2 3 4 5
5 4 3 2 1
5 6 7 8 9 10 2 1 2
10 9 8 7 6
3 4 5 6
7 8 9 10
H1 H2 H3 H4 I1 I2
12345 12345
1 2 1 2
1 2 3 4 1
3 4 5 6 3 4 5 6
5 6 7 8 9 10 2
336
YARIS (EM02C4EL)
K
I3 I4 J1 J1 J2 J2 J3
(*12) (*6) Black (*12) (*6) Black
1 2
1 1 1 1
1 2 3 4 1 3 4
5 6 7 8 9 10 2 5 6
J4 J5 J8 J9 J12
Yellow Yellow
1 2 3 4 5 1 2 3 4 5
1 2 1 2
1 2 3
3 4
4 5 6 7 8 9 10 6 7 8 9 10
5 6
11 12 13 14 15 11 12 13 14 15
1 2 1 2
1 2 3 4 5
1 2 3 4 5 6
7 8 9 10 11 12
1 2
1 1
1 2
1 2 3 4 5 6
7 8 9 10 11 12
1 1
1 2 1 2 2 1
3 4 3 4 4 3
1 2 3 1 2 3
6 5
337
YARIS (EM02C4EL)
K CONNECTOR LIST
J38 K1 K2 M1 M2 N1
Gray Gray Black
1 2 3
1
1 2 1 2
1 2 1 2
N2 N3 N6 N7 O1 P1
Black Black
1
1 2
1 2 1 2 3 4
1 2 1 2
3 4 3 4
Q1 R1 R2 V2 W1
Orange Black Orange
1 2 1 2
1 2 3 4 5
1 2 6 7 8 9 10
1 2 3 4 5
3 4
5 6 6 7 8 9 10
Z1 a1 b1 c1
Black Black
1 2 1 2
1 1 2 3 4
5 6 7 8
338
YARIS (EM02C4EL)
Memo
339
YARIS (EM02C4EL)
K CONNECTOR LIST
AA1 AA2
1 2 3 4
9 8 7 6 5 4 3 2 1
5 6 7 8 9 10 4 3 2 1 1 2 3 4 5 6 7 8 9
10 9 8 7 6 5 25 16 15 14 13 12 11 10 17
17 10 11 12 13 14 15 16 25 24 23 22 21 20 19 18
18 19 20 21 22 23 24
2 1
4 3 1 2 3 4 5 5 4 3 2 1
1 2
6 7 8 9 10 10 9 8 7 6
3 4
AD3 Black
11 10 9 8 7 6 5 4 3 2 1
1 2 3 4 5 6 7 8 9 10 11
22 21 20 19 18 17 16 15 14 13 12
12 13 14 15 16 17 18 19 20 21 22
9 8 7 6 5 4 3 2 1 5 4 3 2 1
1 2 3 4 5 6 7 8 9 1 2 3 4 5
18 17 16 15 14 13 12 11 10 9 8 7 6
10 11 12 13 14 15 16 17 18
6 7 8 9
17 16 15 14 13 12 11 10
10 11 12 13 14 15 16 17
340
YARIS (EM02C4EL)
K
AD6 AE1
1 2 3 4 1 2 3 4
5 6 7 8 9 10 4 3 2 1 5 6 7 8 9 10 4 3 2 1
10 9 8 7 6 5 10 9 8 7 6 5
AJ1 BA1
7 6 5 4 3 2 1 5 4 3 2 1
1 2 3 4 5 6 7 1 2 3 4 5
8 9 10 11 12 13 14 14 13 12 11 10 9 8 9 8 7 6
6 7 8 9
17 16 15 14 13 12 11 10
10 11 12 13 14 15 16 17
CA1 CA2
5 4 3 2 1
1 2 2 1 1 2 3 4 5
5 5 9 8 7 6
3 4 6 7 7 6 4 3
10 10 6 7 8 9
8 9 11 12 12 11 9 8
13 14 15 15 14 13 17 16 15 14 13 12 11 10
10 11 12 13 14 15 16 17
2 1
1 2
9 8 7 6 5 4 3 2 1
1 2 3 4 5 6 7 8 9
18 17 16 15 14 13 12 11 10
10 11 12 13 14 15 16 17 18
341
YARIS (EM02C4EL)
K CONNECTOR LIST
DE2 DQ2 Yellow ED1
1 2 2 1 1 2 2 1
1 2
2 1
FD1
1 10
10 1
11 2 3 4 5 6 7 8 9 20
12 13 14 15 16 17 18 19 20 9 8 7 6 5 4 3 2 11
19 18 17 16 15 14 13 12
1 2 8 9 4 3 2 1
1 2 3 4
9 8 2 1 5 6 7 8 8 7 6 5
10 11 3 4 5 6 7 17 18
12 13 14 15 16 18 17 7 6 5 4 3 11 10
16 15 14 13 12
GD1
1 10
10 1
11 2 3 4 5 6 7 8 9 20
12 13 14 15 16 17 18 19 20 9 8 7 6 5 4 3 2 11
19 18 17 16 15 14 13 12
342
YARIS (EM02C4EL)
K
GD2
1 2 8 9
9 8 2 1
10 11 3 4 5 6 7 17 18
12 13 14 15 16 18 17 7 6 5 4 3 11 10
16 15 14 13 12
HJ1
1 2 3 4 5
6 7 8 9 5 4 3 2 1
9 8 7 6
10 11 12 13 14 15 16 17
17 16 15 14 13 12 11 10
IJ1
1 2 3 4 5
6 7 8 9 5 4 3 2 1
9 8 7 6
10 11 12 13 14 15 16 17
17 16 15 14 13 12 11 10
JD1
1 2 8 9
9 8 2 1
10 11 3 4 5 6 7 17 18
12 13 14 15 16 18 17 7 6 5 4 3 11 10
16 15 14 13 12
343
YARIS (EM02C4EL)
K CONNECTOR LIST
JD2
1 10
10 1
11 2 3 4 5 6 7 8 9 20
12 13 14 15 16 17 18 19 20 9 8 7 6 5 4 3 2 11
19 18 17 16 15 14 13 12
MJ1 MN1
5 4 3 2 1 5 4 3 2 1
1 2 3 4 5 1 2 3 4 5
9 8 7 6 9 8 7 6
6 7 8 9 6 7 8 9
17 16 15 14 13 12 11 10 17 16 15 14 13 12 11 10
10 11 12 13 14 15 16 17 10 11 12 13 14 15 16 17
ZJ1 aJ1
1 2 2 1 1 2 2 1
344
YARIS (EM02C4EL)
K
*1 : LHD Before Jan. 2008 Production, RHD Before Jan. 2009 Production
*2 : LHD From Jan. 2008 Production, RHD From Jan. 2009 Production
345
YARIS (EM02C4EL)
L PART NUMBER OF CONNECTORS
Code Part Name Part Number Code Part Name Part Number
A1 Turn Signal Lamp (Front Side RH) B13 Junction Connector 90980-11661
90980-11162
A2 Turn Signal Lamp (Front Side LH) B14 Headlamp Leveling Motor (RH)
90080-98028
A3 Pressure SW 90980-10943 B15 Headlamp Leveling Motor (LH)
A4 Rear Washer Motor 90980-11051 B16 Headlamp Assembly (RH)
90980-10942
A5 Windshield Washer Motor 90980-11019 B17 Headlamp Assembly (LH)
A6 Airbag Sensor (Front RH) 90980-12490 B18 Turn Signal Lamp (Front RH) 82824-52130
A7 Speed Sensor (Front RH) 90980-11003 B19 Turn Signal Lamp (Front RH) 90980-11019
A8 Cooling Fan Motor 90980-10928 B20 Clearance Lamp (RH) 90080-98298
A9 Windshield Wiper Motor 90980-11599 B21 Clearance Lamp (RH) 90980-11156
A10 Brake Fluid Level Warning SW 90980-11207 B22 Clearance Lamp (LH) 90080-98298
A11 Speed Sensor (Front LH) 90980-11003 B23 Clearance Lamp (LH) 90980-11156
A12 Airbag Sensor (Front LH) 90980-12490 B24 Turn Signal Lamp (Front LH) 82824-52130
A13 Stop Lamp SW 90980-11118 B25 Turn Signal Lamp (Front LH) 90980-11019
A14 Radiator Fan Resistor 90980-10928 C1 Starter 90980-09640
A15 Skid Control ECU with Actuator 90980-12020 C2 Crankshaft Position Sensor 90980-12028
A16 Clutch Start SW 90980-10825 C3 VSV (Purge) 90980-11156
Power Steering ECU C4 Fuel Injector (No.1)
(LHD Before Jan. 2008 Production, RHD 90980-12300
Before Jan. 2009 Production) C5 Fuel Injector (No.2)
A19 90980-11875
Power Steering ECU C6 Fuel Injector (No.3)
(LHD From Jan. 2008 Production, RHD From 90980-12653 C7 Fuel Injector (No.4)
Jan. 2009 Production)
C8 A/C Compressor 90980-11271
A20 Accelerator Position Sensor 90980-12303
C9 Alternator 90980-11964
A21 Engine ECU 90980-12462
C10 Alternator 90980-09373
A24 Junction Connector 90980-11661
C11 Ignition Coil (No.1)
A25 Junction Connector 90980-11915
C12 Ignition Coil (No.2)
A26 Junction Connector 90980-11398 90980-11885
C13 Ignition Coil (No.3)
A27 Fusible Link Block 90980-11996
C14 Ignition Coil (No.4)
A28 Fusible Link Block 90980-11775
C15 Starter 90980-11400
A30 Wireless Door Lock Buzzer 90980-11142
C16 Engine Oil Pressure SW 90980-11363
A33 Engine Hood Courtesy SW 90980-11003
C17 Throttle Body Assembly 90980-11858
A34 Security Horn 90980-11235
C18 Camshaft Position Sensor 90980-10947
A35 Option Connector 90980-10860
C19 Water Temp. Sensor 90980-10735
A36 Option Connector 90980-11028
C20 Engine ECU 90980-12399
A37 Junction Connector 90980-11915
C22 Back-Up Lamp SW 90980-11051
A38 Skid Control ECU with Actuator 90980-12659
C23 Speed Sensor 90980-11143
Turn Signal Lamp (Front RH)
90980-11019
B1 (Except HID Type) C24 Camshaft Timing Oil Control Valve 90980-11162
Turn Signal Lamp (Front RH) (HID Type) 82824-52130 C25 Noise Filter (Ignition) 90980-10843
B2 Horn 90980-10619 C26 Air Flow Meter 90980-11317
B3 Clearance Lamp (RH) 90980-11156 C27 Park/Neutral Position SW 90980-12362
B4 Headlamp (RH) C28 ECT Solenoid 90980-11658
90980-11314
B6 Headlamp (LH) C29 Speed Sensor (Turbine) 90980-11156
B7 Clearance Lamp (LH) 90980-11156 C30 Fusible Link Block 90980-09223
Turn Signal Lamp (Front LH) C36 Oxygen Sensor (Bank 1 Sensor 1) 90980-10869
90980-11019
B8 (Except HID Type)
C37 Noise Filter (Ignition) 90980-12792
Turn Signal Lamp (Front LH) (HID Type) 82824-52130
B9 Fog Lamp (Front RH)
82824-60460
B10 Fog Lamp (Front LH)
Note:Not all of the above part numbers of the connector are established for the supply.
346
YARIS (EM02C4EL)
L
Code Part Name Part Number Code Part Name Part Number
Combination Meter D40 Junction Connector 90980-11542
90980-12200
(Before Jan. 2008 Production)
D41 Junction Connector
D1 Combination Meter 90980-11915
(From Jan. 2008 Production until Oct. 2009 90980-12554 D42 Junction Connector
Production, From Oct. 2009 Production) D43 Fuse Block 82610-52010
Combination Meter D44 Diode (Starter) 90980-10962
90980-12155
(Before Jan. 2008 Production)
D2 D45 ACC Cut Relay 82660-52040
Combination Meter
(From Jan. 2008 Production until Oct. 2009 90980-12553 D46 Front Fog Light Relay 82660-52030
Production, From Oct. 2009 Production)
D47 Tweeter (RH)
Spiral Cable 90980-12304
90980-12183 D48 Tweeter (LH)
D3 (Before Jan. 2008 Production)
Spiral Cable (From Jan. 2008 Production) 90980-12552 D52 Headlamp Leveling SW 90980-11950
347
YARIS (EM02C4EL)
L PART NUMBER OF CONNECTORS
Code Part Name Part Number Code Part Name Part Number
Rear Window Defogger SW J31 Noise Filter (Rear Window Defogger) 90980-10916
(Before Jan. 2007 Production, From Jan. 90980-12217
2007 Production until Jan. 2008 Production) J32 Door Courtesy SW (Rear RH)
E6 82824-52010
Rear Window Defogger SW J33 Door Courtesy SW (Rear LH)
90980-12558
(From Jan. 2008 Production) J34 Front Seat Inner Belt (RH)
90980-10795
A/C Amplifier J35 Front Seat Inner Belt (LH)
90980-12410
E8 (Before Jan. 2008 Production)
Electrical Key Oscillator
A/C Amplifier (From Jan. 2008 Production) 90980-12555 (Inside Luggage Room) 90980-12296
E10 Junction Connector 90980-11915 (Before Jan. 2008 Production)
J36
F1 Power Window SW (Front RH) 90980-10789 Electrical Key Oscillator
(Inside Luggage Room) 90980-12695
F2 Outer Rear View Mirror (RH) 90980-12189 (From Jan. 2008 Production)
Power Window Regulator Motor Electrical Key Oscillator
F4 90980-10797 J37 90980-12381
(Front RH) (Outside Luggage Room)
F5 Door Lock Assembly (Front RH) 90980-12226 J38 License Plate Lamp 90980-11162
F6 Speaker (Front Door RH) 90980-10935 K1 Map Lamp 90980-11212
F7 Power Window Master SW 90980-12122 K2 Room Lamp (Center) -
Power Window Regulator Motor M1 Center Stop Lamp 90980-10860
F8 90980-12328
(Front RH)
M2 Rear Window Defogger 90980-11853
F9 Outer Rear View Mirror (RH) 90980-12367
N1 Rear Wiper Motor Assembly 90980-10860
G1 Power Window Master SW 90980-12122
N2 Back Door Lock Assembly 90980-10795
G2 Outer Rear View Mirror (LH) 90980-12189
N3 Back Door Lock Assembly 90980-10825
G4 Power Window Regulator Motor (Front LH) 90980-10797
N6 Luggage Electrical Key SW 90980-12211
G5 Door Lock Assembly (Front LH) 90980-12226
N7 Back Door Lock Assembly 90980-11150
G6 Speaker (Front Door LH) 90980-10935
O1 Rear Window Defogger 90980-11853
G7 Power Window SW (Front LH) 90980-10789
P1 Knock Control Sensor (Bank 1) 90980-11875
G8 Power Window Regulator Motor (Front LH) 90980-12328
Airbag Squib
Q1 90980-12576
G9 Outer Rear View Mirror (LH) 90980-12367 (Front Passenger's Airbag Assembly)
H1 Power Window SW (Rear RH) 90980-10631 R1 Door Outside Handle (Front RH) 90980-12382
H2 Power Window Regulator Motor (Rear RH) 90980-10797 R2 Electrical Key Oscillator (Front Door RH) 90980-12380
H3 Door Lock Assembly (Rear RH) 90980-12226 Spiral Cable
H4 Speaker (Rear RH) 90980-10935 V2 Steering Pad SW 90980-12361
I1 Power Window SW (Rear LH) 90980-10631 Horn SW
I2 Power Window Regulator Motor (Rear LH) 90980-10797 Airbag Squib (Steering Wheel Pad)
W1 90980-12224
I3 Door Lock Assembly (Rear LH) 90980-12226 Spiral Cable
I4 Speaker (Rear LH) 90980-10935 Z1 Speed Sensor (Rear RH)
90980-12416
J1 Door Courtesy SW (Front RH) a1 Speed Sensor (Rear LH)
82824-52010
J2 Door Courtesy SW (Front LH) Power Steering Motor
b1 90980-12299
J3 Rear Combination Lamp (RH) Power Steering ECU
90980-11011
J4 Rear Combination Lamp (LH) Power Steering Torque Sensor
c1 90980-12221
J5 Fuel Suction Pump and Gage Assembly 90980-11077 Power Steering ECU
J8 Airbag Sensor Assembly Center 90980-12449
J9 Airbag Sensor Assembly Center 90980-12450
J12 Room Lamp (Luggage) 90980-11148
J13 Door Control Receiver 90980-12366
J20 Pretensioner (RH)
90980-12253
J21 Pretensioner (LH)
J28 Junction Connector
90980-11661
J29 Junction Connector
J30 Diode (Room Lamp) 90980-10962
Note:Not all of the above part numbers of the connector are established for the supply.
348
YARIS (EM02C4EL)
Memo
349
YARIS (EM02C4EL)
* The system shown here is an EXAMPLE ONLY. It is different to the
350
HOW TO READ THIS SECTION actual circuit shown in the wiring diagram section.
[A]
S ta rtin g E n g in e C o n tro l
1 2 3 4
B- R B- R
B- R
ACC
2
[M]
B- W
W 4 AM1 IG1 A11
1 (BAT) Heated Oxygen Sensor
ST1 1 B- W
7. 5A 15A
IGN EFI
8 AM2 IG2 7 B- R [L]
2 2
ST2 2 B- L
2 3 1
(2L- T) 2 2
W- R
GR
B
[B] A
A6
R- Y
B- W
Ignition SW R- Y R- Y
B- L B
B
R- Y
C
[E] 1 1
B- R
3 4
[H]
W EFI MAIN
B- L
(2L-T)
(2L- T) 7 BA3 Relay 12 BA1
B
[C] [J]
Y- R
(Shielded)
1 2
W
W- R
1 A 1 B
B- R
1 1
2 2 A40(A), A41(B) [I]
Starter
Y- R
Relay
B- W
21
B- W
W- B
Y- R Y- R Y- R
(22R- E)
2 2 BA3 D
2 A 2 B
Y- R
Y- R
2 3 7 3C
B- W
W- B
(2L-T)
(2L- T)
B- W
[F]
YARIS (EM02C4EL)
8 4
40A AM1
30A AM2
6 AB3
100A ALT
B- W
+B OX1
A19
Circuit Opening
Relay
M OVERALL ELECTRICAL WIRING DIAGRAM
(22R- E)
[G] 1 6 15 3C
B- W
1
B- R
R- G
(2L- T)
B- R B- R B- R FP E1
Emission ECU
< 9- 8>
B1
Data Link Connector 1
B- W
2 5 AD2 [D] 1 3
B- R
B- R
B- R
B- R
1 A
R- G
R- G
W- B
2 2 2 2
B
R- G
16 AD1
B 1
B M
17 BA3
B9
Injection No. 1
B11
Injection No. 2
B10
Injection No. 3
B12
Injection No. 4
R- G
1 1 1 1
B38(A), B39(B)
BR
BR
Starter
2
R- G
W- R
W- R
W- R
W- R
M W- R W- R W- R W- R
Battery
A37
Fuel Pump
E
1 W- R W- R
F
W- B
W- B
[K]
A1 A1 A3 B1
[A] : System Title [F] : Junction Block (The number in the circle is the J/B No.
and the connector code is shown beside it).
[B] : Indicates the wiring color.
Junction Blocks are shaded to clearly separate them
Wire colors are indicated by an alphabetical code. from other parts.
B = Black W = White BR = Brown
L = Blue V = Violet SB = Sky Blue Example:
R = Red G = Green LG = Light Green
3C indicates that
P = Pink Y = Yellow GR = Gray it is inside
Junction Block
O = Orange BE = Beige No.3
The first letter indicates the basic wire color and the
second letter indicates the color of the stripe.
Example: L–Y
YARIS (EM02C4EL)
or specification is different.
[J] : Indicates a shielded cable.
Female Male
351
SYSTEM INDEX
352
SYSTEMS LOCATION SYSTEMS LOCATION
ABS (Before Oct. 2009 Production) .................................................. 19-1 Remote Control Mirror ...................................................................... 28-1
ABS (From Oct. 2009 Production) .................................................... 36-1 Seat Belt Warning ............................................................................. 14-7
Air Conditioner (Before Jan. 2009 Production) ................................. 33-1 Shift Lock .......................................................................................... 27-3
Air Conditioner (From Jan. 2009 Production) ................................... 35-1 Smart Entry & Start System ................................................................ 2-1
Audio System ................................................................................... 30-1 * Engine Immobiliser
Back-Up Light ................................................................................... 16-1 * Push-Button Start
Charging ............................................................................................. 4-1 * Steering Lock
Cigarette Lighter ............................................................................... 28-4 * Wireless Door Lock Control
Combination Meter ........................................................................... 31-1
SRS .................................................................................................. 20-1
Cooling Fan ...................................................................................... 32-1
Starting (w/o Smart Entry & Start System) ......................................... 3-1
DLC3 .................................................................................................. 7-1
Stop Light ......................................................................................... 16-3
Door Lock Control (LHD) .................................................................. 24-1
Taillight ............................................................................................. 15-1
Door Lock Control (RHD) ................................................................. 25-1
Theft Deterrent (LHD) ..................................................................... 24-10
ECT and A/T Indicator ...................................................................... 6-17
Theft Deterrent (RHD) .................................................................... 25-10
Engine Control .................................................................................... 6-1
Turn Signal and Hazard Warning Light (LHD) .................................. 12-1
Engine Immobiliser System (w/o Smart Entry & Start System) ........ 34-1
Turn Signal and Hazard Warning Light (RHD) ................................. 13-1
EPS .................................................................................................. 21-1
Wireless Door Lock Control (LHD) ................................................... 24-9
Front Fog Light ................................................................................. 17-1
Wireless Door Lock Control
Front Wiper and Washer .................................................................. 26-1
(RHD w/o Smart Entry & Start System) ............................................ 25-9
Headlight (Except HID Type) ............................................................ 10-1
Headlight (HID Type) .......................................................................... 9-1
Headlight Beam Level Control .......................................................... 11-1
YARIS (EM02C4EL)
M OVERALL ELECTRICAL WIRING DIAGRAM
354
∗ 1 : w/ Smart Entry & Start System
∗ 2 : w/o Smart Entry & Start System
P o w e r S o u rc e ∗ 3 : HID Type
∗ 4 : Except HID Type
1 2 3 4
B
A
50A EPS
1
B 1 2
1E
1 2 1 2
1 2 1 2
GR
B
15A AM2 30A ABS2/VSC2 (∗1)
IG2 Relay
1
W 1 2 1 2
1C
3 1B 2 1B 4 1B 1 1B
7. 5A ALT–S 30A RDI
1
1 2 1 2 P
1D C
(∗1)
15A DOME
P
W
GR
1 2 L
1
Charging System
< 4–1>
(∗2)
14 AA2
30A ST
B
B
W
1 2
P
YARIS (EM02C4EL)
P
1 2 1 2
M OVERALL ELECTRICAL WIRING DIAGRAM
(∗1)
120A ALT
60A MAIN
P
W
(∗2)
W–B
B(∗3)
B(∗3)
B(∗3)
Battery 10A H–LP RH/H–LP LO RH 15A H–LP LO LH W
E
(∗4) 1 2 1 2
P
1 2 F
7 (∗2)
20A S–LOCK 15A H–LP LO RH
L
1 2 5 3 B 1 2 G
7 7 1 (∗2)
(∗3)
H–LP Relay
30A H–LP MAIN
1 2 B
1
(∗3) A1
1 YARIS (Cont' d) (Cont. next page)
5 6 7 8
B B
A A
1 6 G
C AM1 IG1D C
(∗1)
O
(∗1 ∗10)
4 4
BE(∗1 ∗9)
LG
ACCD F B
(∗1)
(∗7)
(∗8)
6 Y
GR 5 7 SB 6 6 9 L B
F B AM2 SSW2 C (∗1)
B
(∗1) (∗1) (∗1)
Y
(∗7)
(∗8)
D36
Junction
C
(∗2)
Y
10
LG
(∗1)
(∗1)
Connector R
SSW1 C
(∗1)
G
P 5 ACC 2 W(∗2) D
C IG2D (∗1)
C 7 2
(∗1)
Y 4 AM1 IG1 1 G(∗2) G
SS1 SS2 E
2 5 (∗2) (∗2)
SS1 SS2 GND
Free
D73
ACC Relay
GR 5 AM2 IG2 6 P
1 3
Full
Traveling (∗2) (∗2) 4 1 3 2
ST2 W 7. 5A ACC2 B
P A B A B
(∗2) (∗2)
(∗2)
W
(∗2)
(LHD)
(LHD)
(RHD)
(RHD)
D8 D43(A), (B)
D55
Power SW
GND COM Ignition SW Fuse Block
5 4
2 A 3 A (∗10)
8 4S 2 B 3 B (∗9)
YARIS (EM02C4EL)
(∗1)
(∗1)
(∗1)
(∗1)
W–B
W–B
W–B
D45(A), (B)
ACC Cut Relay
(∗2)
(∗2)
L
F
(∗2)
GR 18 AD4
D
(∗2)
W W
E G
G
(∗2)
P
F
(∗2)
L
G
(∗2) Engine ECU
< 6–7>
L
H
(∗1)
(∗1)
(∗1)
W–B
W–B
D2 D1
M
355
1 YARIS (Cont' d)
356
∗ 1 : w/ Smart Entry & Start System
∗ 2 : w/o Smart Entry & Start System
P o w e r S o u rc e ∗ 5 : w/ Theft Deterrent System
∗ 6 : w/o Theft Deterrent System
9 10 11 12
1 (∗5) (∗5) (∗5)
B
A 4G
10A TAIL
(∗5) (∗5) (∗5)
7. 5A PANEL1
T–LP Relay
30A DEF
1 2 10A ID/UP
15A FR FOG
DEF Relay
Y
B 7. 5A OBD2
(∗1)
1
Y
C 4F (∗6) 10A TAIL (∗6) 4
(∗2) W
4M
(∗6)
10A STOP
G
D
(∗1) 20A D DOOR
3 30A POWER
G PWR Relay
E 4F 1 2 5
(∗2)
B1
25A D/L
B1 T1
20A RL DOOR
Light OFF D4
Control Headlamp Dimmer SW
25A AM1 20A RR DOOR SW Tail Assembly
Head
7. 5A RR FOG
T1
Noise Filter
8
YARIS (EM02C4EL)
IG 1 Relay
M OVERALL ELECTRICAL WIRING DIAGRAM
5 3 10A ECU–IG
2 1 20A WIP
10 7. 5A PANEL2 7. 5A PANEL1
G
4E
5 7. 5A ACC 15A WSH (∗6)
L
F 4F
(∗2)
15A CIG 10A GAUGE
7. 5A IGN 7. 5A A/C
17 4E
W–B
L
H
(∗1)
D2
Memo
358
S m a rt E n try & S ta rt S y s te m
1 2 3 4
D64(B), (F), D65(C), D66(D)
(BAT) (IG) (BAT) Main Body ECU
∗ 1 : w/ ABS
30A ∗ 2 : w/o ABS 7. 5A 15A
ST ∗ 3 : From Jan. 2008 Production IGN AM2
∗ 4 : Before Jan. 2008 Production AM1 AM2 STR STR2 STP TACH STSW ACCR P
∗ 5 : From Jan. 2009 Production
2 2 1 C 6 F (∗3) 3 D 14 D 14 F (∗3) 2 D 4 D 11 D 15 F (∗3)
∗ 6 : Before Jan. 2009 Production
6 B (∗4) 14 B (∗4) 15 B (∗4)
1 21 4E 1 1B
L
B
P
O
G
G
BE
SB
GR
(∗5)
(∗6)
GR
B
W
O
(∗6)
BE(∗5)
4 AD2 6 A 7 A
1 1 9 AD4 18 AD4
5 A D36(A)
B
G
Junction
Connector
DLC3
< 7–4>
5 2
GR
Shift Lock
Control ECU
< 27–4>
ST
Stop Lamp SW
< 16–3>
Relay
3 1
B
Engine ECU
< 6–7>
1 1
A25(A), A37(B)
Junction 15 A (∗1)
Connector 15 B (∗2)
17 A 16 A (∗1)
12 B 14 B (∗2) R
V
A
W–B
R
R
BR
GR
GR
14 A
GR STSW
A21(A), C20(B)
Engine ECU
9 CA1 10 AD4
2 5 STA STAR
48 A 52 B
W
10 CA1 D67
Y
ST Cut
YARIS (EM02C4EL)
Relay
5
M OVERALL ELECTRICAL WIRING DIAGRAM
BE
BR
(∗5)
(∗6)
13 AA2 1 3
B L BE(∗5)
V
C27
P Park/Neutral O
Position SW 5 AA2 8 CA1
Y
1 B (∗6)
1 N
A
4 1 A (∗1)
O
O
BE
BR
(∗6)
(∗5)
(∗6)
W–B
1 B (∗2)
BE(∗5)
GR
A25(A), A37(B)
Junction
Connector
M
2 A (∗1) 12 AA2
B
W–B
2 B (∗2)
C1(A), C15(B) 10 CA2
Starter
O
BE
(∗5)
(∗6)
GR
1 AD4
Battery
O(∗6)
W–B
BE(∗5)
A1 D1
2 YARIS (Cont' d) (Cont. next page)
S m a rt E n try & S ta rt S y s te m
5 6 7 8
9 4D
(BAT) 7. 5A
L
ECU–B
GR
30 4B 2 4S 3 4D
Multiplex
Communication
System (CAN)
< 8–2>
M 20A
S–LOCK 2
L
L
L
P
D56 2 25
3 4 Steering Lock ECU L
AA2
IGE SLP1 1
Multiplex
Communication
System (CAN)
< 8–1>
21 E 20 E 2 E (∗8)
R
21 C 20 C 2 C (∗7)
IG2 SGND GND LIN B 21 A 20 A 2 A (∗4)
6 2 1 5 7
9 AD2
P
R
W–B
W–B
R CAN I/F Display
P P
Electronic Key
R
A CAN Controller
P
P
CPU LED Driver
D58(A), (B) 3 B (∗3)
ID Code Box 3 A (∗4)
LIN1
YARIS (EM02C4EL)
8 B 1 B 6 B 5 B (∗3)
8 A 1 A 6 A 5 A (∗4)
24 E (∗8) D1(A), (C), (E)
24 C (∗7) Combination Meter
24 A (∗4)
W
BE
(∗5)
(∗6)
L
∗ 3 : From Jan. 2008 Production
∗ 4 : Before Jan. 2008 Production
8 AD4 17 AD4
∗ 5 : From Jan. 2009 Production
∗ 6 : Before Jan. 2009 Production
∗ 7 : From Jan. 2008 Production until Oct. 2009 Production
∗ 8 : From Oct. 2009 Production
W–B
W–B
W–B
O
W
BE
(∗5)
(∗6)
P
B
Engine ECU
< 6–8>
3 6A 6 6A
BR
D1 D2 D3
M
359
2 YARIS (Cont' d) (Cont. next page)
360
∗ 3 : From Jan. 2008 Production
∗ 4 : Before Jan. 2008 Production
S m a rt E n try & S ta rt S y s te m ∗ 5 : From Jan. 2009 Production
∗ 6 : Before Jan. 2009 Production
9 10 11 12
W–B
SB
LG
D61(A), (B) J36(A), (B)
7 2 13 12 11 Electrical Key Electrical Key Oscillator
12 4H SS1 SS2 INDW INDS SWIL Oscillator (Front) (Inside Luggage Room)
Transponder Key Coil
P
SS1 SS2 GND
Free
Power Source
System< 1–6>
CLG3 CLGB CLG6 CLGB
11 A Full 1 B 3 B (∗3) 1 B 3 B (∗3)
Traveling
1 A 3 A (∗4) 1 A 3 A (∗4)
D36(A)
Junction Connector
9 A
V
P
B
G
LG
Power SW
V
P
BR
V
P
W–B
W–B
O
BE
(∗5)
(∗6)
W–B W–B
1 40 8 9 30 11 12 15 16
+B AGND TXCT CODE VC5 CLG5 CG5B CLG7 CG7B
L
R
W
GR
YARIS (EM02C4EL)
4 AD4 14 JD1 15 JD1 16 JD1
M OVERALL ELECTRICAL WIRING DIAGRAM
L
R
W
P
GR
W–B
1
Multiplex
Communication
System (CAN)
< 8–1> < 8–2>
4 5 2
+5 DATA RSSI
P GND
A30
Wireless Door Lock Buzzer
B
2 J13 1
Door Control Receiver
W–B
W–B
W–B
W–B
W–B
W–B
D1 D2 A2 J2
2 YARIS (Cont' d) (Cont. next page)
∗ 3 : From Jan. 2008 Production
∗ 4 : Before Jan. 2008 Production
S m a rt E n try & S ta rt S y s te m ∗ 5 : From Jan. 2009 Production
∗ 6 : Before Jan. 2009 Production
13 14 15 16
Y
J37 10A 7. 5A
Electrical Key Oscillator 21 4A 24 4A 20 4A 5 4A 7 4A
ECU–IG ACC 15A
(Outside Luggage Room)
DOME
9 JD1
Door Lock
Control System
< 25–4>
2
1
Y
7 4S 6 4S
CLG5 CLGB
1 2
R
GR
L
BR
8 B 13 B
LG
SB
D36(A), D37(B) D34(A), D35(B)
Junction Junction
Connector Connector
Y
Y
LG
SB
BR
BR
BR
D60
31 32 18 19 Certification ECU 7 4 4P
CLG8 CG8B IG ACC TSW5 13 MN1 14 MN1
Y
BR
3 5 22 33 34 25 24 2
4 1
W
P
V
P
R
R
O
BE
LG
GR
(∗5)
(∗6)
UL B
YARIS (EM02C4EL)
7 FD2 R 4 FD2 5 FD2 6 FD2 15 FD2 3 FD2 1 B
LOCK
Opener
G D38(A), D39(B)
Junction
W
Connector
B
Y
B
V
O
(∗6)
L E L 9 A
BE(∗5)
N6
Luggage Electrical Key SW
7 FR1 3 2
W
6 FR1 4 FR1 3 FR1 2 FR1 1 FR1 8 FR1
Security Indicator
Lamp< 25–12>
Theft Warning
ECU< 25–10>
B
W–B
W–B
V
P
Y
O
BR
W–B
3 6 5 2 1 9 8 3 2 4 6 10 5 1 7
V
TRG+ SGT ANT1 ANT2 TRG– TRG– ANT2 ANT1 SGT SEL SENS CLG CLGB +B GND
R1 R2
W–B
Door Outside Handle (Front RH) Electrical Key Oscillator (Front Door RH)
2 6B
D2 N1
M
361
2 YARIS (Cont' d)
362
∗ 3 : From Jan. 2008 Production
∗ 4 : Before Jan. 2008 Production
S m a rt E n try & S ta rt S y s te m ∗ 5 : From Jan. 2009 Production
∗ 6 : Before Jan. 2009 Production
17 18 19 20
(BAT)
25A
D64(B), (F), D65(C), D66(D) D/L
Main Body ECU
LSWD LSWP UL2 L2 ACT– ACT+ TLH TR+ GND1 ALTB
25 F 10 F (∗3) 16 14 3 2 13 C 1 F (∗3) 1 4
25 B 10 B (∗4) 1 B (∗4)
G
BE
(∗5)
(∗6)
17 4E
8 JD1
BE
(∗5)
(∗6)
PANEL1 Fuse
< 15–8>
W–B
BE
(∗5)
(∗6)
4 2
YARIS (EM02C4EL)
M OVERALL ELECTRICAL WIRING DIAGRAM
Courtesy
Interior Light System
< 14–2>
N2
Back Door Lock Assembly
3 1
W–B
W–B
N1 D2
3 YARIS
1 2 3 4
(BAT) (BAT)
D8
GR
GR
W
Ignition SW 9 AD4
B
B
1 4 AD2
14 A 1
STSW D44
5 2
Diode (Starter)
ST STA STAR
2
A21(A), C20(B)
Engine ECU
Relay 48 A 52 B
3 1
BE
SB
BR
(∗3)
(∗4)
1 1 1
5 AA2 8 CA1
V
B
W–B
O
BE
(∗3)
(∗4)
15 A (∗1)
15 B (∗2)
A25(A), A37(B)
Junction
Connector 12 AA2
18 A 16 A 17 A (∗1)
13 B 14 B 12 B (∗2)
O
BE
(∗3)
(∗4)
B
W
BR
(A/T)
(M/T)
1 AD4
10 CA1 9 CA1
YARIS (EM02C4EL)
W
O
BE
(∗3)
(∗4)
(A/T)
V
5 7 5
1 D36
B L C27 Junction Connector
1 B
1 Park/Neutral
A P Position SW 6
GR
A16
Clutch Start SW
N
2
M 4
10 AD4
B
GR
(A/T)
C1(A), C15(B)
Y
Starter
10 CA2
13 AA2
Y
GR
Y
(A/T)
(M/T)
Battery
3 A 2 A 1 A (∗1)
3 B 2 B 1 B (∗2)
A25(A), A37(B)
Junction
Connector
A1
M
363
4 YARIS
364
∗ 1 : From Jan. 2008 Production until Oct. 2009 Production
C h a rg in g ∗ 2 : Before Jan. 2008 Production
∗ 3 : From Oct. 2009 Production
1 2 3 4
(IG) (IG)
7. 5A 10A
MET GAUGE
1 4M 19 4B
B
1 E (∗3)
W
1 C (∗1)
1 A (∗2)
W
1
Charge
2
L
1 1D 15 AD3
L
(RHD)
G
W
7 AA2
L
(LHD)
W
Engine ECU
< 6–15>
L
(RHD)
4 CA1
2 B 1 C
YARIS (EM02C4EL)
L
P
M OVERALL ELECTRICAL WIRING DIAGRAM
C9(A), C10(B)
1 B 3 A 1 A Alternator 4 A 2 A
120A ALT
60A MAIN
B M S L IG
A27(B), C30(C)
Fusible Link Block
Battery
IC Regulator
5 YARIS
Ig n itio n
1 2 3 4
GR
(∗1) (BAT)
GR
15A ∗ 1 : w/ Smart Entry & Start System
(∗2) AM2 ∗ 2 : w/o Smart Entry & Start System
D8
Ignition SW ∗ 3 : From Jan. 2008 Production
∗ 4 : Before Jan. 2008 Production
2 ∗ 5 : From Jan. 2009 Production
∗ 6 : Before Jan. 2009 Production
5 AM2 IG2 6 P
(∗2)
ST2
5 5 AD4 4 AD2
D36
Junction Connector
P
P
R
R
(∗1)
SB
(∗1)
14 AA2 11 CA1 R
6 F (∗3)
6 B (∗4) R
P
R
GR
AM2 D64(B), (F), D65(C)
Main Body ECU
LG
IG2D
5 C 2 1B 1 1B 4 1B
R
R
R
LG
BR
C11 C12 C13 C14 1 A (∗6)
P
(∗1)
1 Ignition Coil (No. 1) 1 Ignition Coil (No. 2) 1 Ignition Coil (No. 3) 1 Ignition Coil (No. 4) 1 B (∗5)
+B +B +B +B
IG2
Relay
C25(A), C37(B)
Noise Filter
(Ignition)
GND IGT IGF IGF IGT2 GND IGF GND IGT3 IGF GND IGT4
4 3 2 2 3 4 2 4 3 2 4 3
3 1B
YARIS (EM02C4EL)
L
Y
Y
Y
G
W
LG
W–B
W–B
W–B
W–B
W–B
O(∗6)
BE(∗5)
Y Y
Y W–B W–B
W–B
Engine ECU
< 6–11>
A1 C1
M
365
6 YARIS (Cont. next page)
366
∗ 1 : w/ Smart Entry & Start System
∗ 2 : w/o Smart Entry & Start System
E n g in e C o n tro l ∗ 5 : From Jan. 2008 Production
∗ 6 : Before Jan. 2008 Production
1 2 3 4
(BAT) (BAT) (IG)
20A 15A 7. 5A
EFI AM2 IGN
SB
(∗1)
2 2
6 F (∗5)
6 B (∗6)
AM2 C/OPN
EFI IG2 5 AM2 IG2 6 Relay
Relay Relay
ST2 IG2D
SB
(∗1)
D8 27 4B 9 4B 5 4E 11 4B 8 4A
1 1A 4 1A 3 1A 2 1A 3 1B 2 1B 4 1B 1 1B Ignition SW
7
P
P
GR
(∗2)
(∗2)
(∗1)
D36
Junction
Connector
5
Y
B
P
P
V
B
B
R
R
GR
GR
W–B
W–B
P
A
GR
(∗1)
14 AA2 4 AD2 5 AD4
11 CA1
P
P
4
R
M
Pump
J5
Fuel Suction Pump and
Gage Assembly
R
R
LG
BR
1 1 1 1
YARIS (EM02C4EL)
W–B
M OVERALL ELECTRICAL WIRING DIAGRAM
V
B
C4
Fuel Injector (No. 1)
C5
Fuel Injector (No. 2)
C6
Fuel Injector (No. 3)
C7
Fuel Injector (No. 4)
R
2 2 2 2 C
L L
SB
D
GR
P
E
GR
F
SB
G
GR
H
B B B
I
Y
J
W–B
W–B
W–B
A1 J1
6 YARIS (Cont' d) (Cont. next page)
∗ 1 : w/ Smart Entry & Start System ∗ 5 : From Jan. 2008 Production
∗ 2 : w/o Smart Entry & Start System ∗ 6 : Before Jan. 2008 Production
E n g in e C o n tro l ∗ 3 : w/ Theft Deterrent System ∗ 7 : From Jan. 2009 Production
∗ 4 : w/o Theft Deterrent System ∗ 8 : Before Jan. 2009 Production
5 6 7 8
(BAT)
10A
ETCS
P
2
3 A 2 A (∗8) 1
P
4 B 2 B (∗7)
GR
1
A13(A), (B)
Stop Lamp SW
4 A 1 A (∗8) E2
3 B 1 B (∗7)
THW
C19
Water Temp. Sensor
24 AA2
Stop Lamp SW
< 16–4>
Main Body ECU
< 2–4>
ACC Cut Relay
< 1–8>
TAIL Fuse (∗3)
< 15–4>
Headlamp Dimmer SW
Assembly (∗4)< 15–4>
Stop Light
System< 16–3>
P
G
G
A
(∗1)
(∗2)
L
Y
P
G
G
GR
A21(A), C20(B)
Engine ECU 35 A 36 A 14 A 52 B 48 A 13 A 96 B 97 B 3 A 31 A
ST1– STP STSW STAR STA ACCR ETHW THW +BM ELS
V
P
Y
B
R
SB
GR
GR
L
B
O
W
BE
(∗7)
(∗8)
12 AD4
YARIS (EM02C4EL)
1
V ID Code Box
B < 2–6>
Transponder
R Key ECU< 34–2>
C3
VSV (Purge)
C
2
L
D
P
E
GR
F
SB
G
V
GR
H
B B
I
Y
J
B
W(∗5)
A
1 12
B V V V B(∗6)
AA2 CA1 B
9 5
B B B
AA2 AD5 C
M
367
6 YARIS (Cont' d) (Cont. next page)
368
∗ 5 : From Jan. 2008 Production
∗ 6 : Before Jan. 2008 Production
E n g in e C o n tro l ∗ 7 : From Jan. 2009 Production
∗ 8 : Before Jan. 2009 Production
9 10 11 12
C17
Throttle Body Assembly
Ignition Coils
< 5–2> < 5–3> < 5–4>
A/C Amplifier
< 33–5> < 35–5>
E2 VC VTA VTA2 M+ M–
3 5 6 4 2 1
V
Y
Y
B
R
R
G
G
W
W
LG
LG
GR
O(∗8)
BE(∗7)
(Shielded)
BR
A21(A), C20(B)
91 B 67 B 115 B 114 B 42 B 41 B 63 B Engine ECU 85 B 84 B 83 B 82 B 81 B 22 A 30 A 18 A
ETA VCTA VTA1 VTA2 M+ M– GE01 IGT1 IGT2 IGT3 IGT4 IGF1 FAN2 AC1 ACT
THA E2G VG ETHA HT1A EX1A OX1A HT1B EX1B OX1B KNK1 EKNK NE+ NE– G2+
65 B 116 B 118 B 88 B 109 B 90 B 112 B 47 B 87 B 64 B 110 B 111 B 122 B 121 B 99 B
P
G
G
LG
GR
(Shielded)
(Shielded)
YARIS (EM02C4EL)
L
L
P
P
B
G
W
W
LG
GR
O(∗8)
M OVERALL ELECTRICAL WIRING DIAGRAM
BE(∗7)
(Shielded)
(Shielded)
(Shielded)
W
W
LG
GR
(Shielded)
4 2 3 5 1 4 3 2
THA E2G VG E2 HT1A E2 OX1A 4 AD5 3 AD5 1 AD5 2 AD5 1 2
+B +B
LG
GR
1 C26 2 C36
P1
Knock Control Sensor
(Bank 1)
C2
Crankshaft Position
Sensor
C18
Camshaft Position
Sensor
(Bank 1 Sensor 1) 1 4
1
HT1B E2
B
B
+B OX1B
D28
Oxygen Sensor (Bank 1 Sensor 2)
2 3
B
W
W(∗5)
A
B(∗6) B
BR
C1
B B
C
6 YARIS (Cont' d) (Cont. next page)
E n g in e C o n tro l
13 14 15 16
A20
Accelerator Position Sensor
ID/UP Fuse
< 29–1>
1 3 2 4 6 5
V
B
R
G
W
A21(A), C20(B) BR
Engine ECU 33 A 58 A 56 A 60 A 57 A 55 A 59 A
ELS3 VCP2 VPA2 EPA2 VCPA VPA EPA
OC1+ OC1– EC E1 ME01 E01 E03 ALT E02 TC TACH SPD CANL CANH
100 B 123 B 32 A 104 B 43 B 45 B 86 B 50 B 44 B 27 A 15 A 8 A 49 A 41 A
P
B
P
V
LG
YARIS (EM02C4EL)
Alternator
< 4–2>
DLC3
< 7–3>
R
W
W
BR
BR
BR
W–B
Combination Meter
< 31–3>
Multiplex Communication
System (CAN)< 8–3>
C24
Camshaft Timing Oil Control Valve
2
A1 C2 C1
M
369
6 YARIS (Cont' d)
370
∗ 5 : From Jan. 2008 Production ∗ 8 : Before Jan. 2009 Production
E C T a n d A /T In d ic a to r ∗ 6 : Before Jan. 2008 Production ∗ 9 : From Jan. 2008 Production until Oct. 2009 Production
∗ 7 : From Jan. 2009 Production ∗10 : From Oct. 2009 Production
17 18 19 20
(IG) (IG) (BAT)
G
(A/T)
10A 7. 5A 7. 5A
GAUGE MET ECU–B
1 CA1 2
19 4B
2 1 4M 1 30 4B
RB
1 G
L
L
(A/T)
2 4S
PL RL NL DL 2L LL 16 AA2 (LHD)
C29
Speed Sensor (Turbine)
C27
Park/Neutral Position SW
B
2 6 1 9 7 3 8 25 AA2 (RHD)
L
L
(A/T)
1 E 2 E (∗10)
Park/Neutral Position
SW< 16–1>
1 C 2 C (∗9) D1(A), (C), (E), D2(B), (D), (F)
1 A 2 A (∗6) Combination Meter
B
V
G
G
SB
(A/T)
(A/T)
(A/T)
(A/T)
(A/T)
(A/T)
(A/T)
14 CA1
R
Back–Up Light
System< 16–1>
(A/T)
A21(A), C20(B)
125 B 124 B 53 B 73 B 54 B 55 B 74 B Engine ECU 56 B
L
NT+ NT– R P N 2 L D
(A/T RHD)
5V IC
L
S1 S2 SL SLT+ SLT– ST THO1 ETHO W ODMS 22 AA2
79 B 78 B 57 B 76 B 75 B 80 B 72 B 95 B 24 A 26 A
(A/T LHD)
L
(A/T RHD)
BE
CPU
2 AD3
L
P
Y
B
B
G
W
CAN Controller
SB
YARIS (EM02C4EL)
GR
(A/T)
(A/T)
(A/T)
(A/T)
(A/T)
(A/T)
(A/T)
(A/T)
M OVERALL ELECTRICAL WIRING DIAGRAM
8 AA2
BE
L
5 10 4 3 8 2 1 6
B
Y
O
O
W
LG
GR
9 B (∗5)
O
BE
9 A (∗6)
NSSD 4 F 20 E 21 E 24 E (∗10)
(A/T LHD ∗7)
(A/T LHD ∗8)
4 D 20 C 21 C 24 C (∗9)
4 B 20 A 21 A 24 A (∗6)
AT3
D22(A), (B)
Shift Lock
Control ECU
B
B
(A/T ∗7)
Multiplex
O Communication
System (CAN)< 8–2>
(A/T ∗8)
D3
7 YARIS
∗ 1 : w/ Smart Entry & Start System
∗ 2 : w/o Smart Entry & Start System
DLC3 ∗ 3 : From Jan. 2009 Production
∗ 4 : Before Jan. 2009 Production
1 2 3 4
(BAT)
7. 5A
OBD2
Transponder
Key ECU < 34–4>
Power Steering ECU
< 21–3>
5 4S
W
(∗2)
13 A
Engine ECU
< 6–16>
D34(A), D35(B)
21 B 20 B
L
W
LG
LG
(∗1)
BE
(∗3)
(∗4)
SB
3 4S 31 4E 23 4B 13 AD4
LG
(∗1)
5 A 7 A
7 4E 12 4D LG
(∗2)
6 A D34(A)
Junction
BE(∗1 ∗3) Connector
L
P
O
(∗1 ∗4)
16 7 12 13 9
BAT SIL TS TC TAC
YARIS (EM02C4EL)
CG CANH CANL
4 D15 6 14
DLC3
Multiplex Communication
System (CAN)< 8–2>
W–B
W–B
W–B
D2 D1
M
371
8 YARIS
372
M u ltip le x C o m m u n ic a tio n S y s te m (C A N )
1 2 3 4
Y
B
W
W
W
SB
W
D41
16 5 4 15 11 22 22 11 Junction Connector 8 19
D42 6 17 7 18 3 14 3 14 15 4 1 12
Junction Connector
L
V
V
G
G
W
W
W
W
W
W
YARIS (EM02C4EL)
GR
(∗1)
(∗1)
(LHD)
(LHD)
(RHD)
(RHD)
M OVERALL ELECTRICAL WIRING DIAGRAM
W
W
20 E 21 E (∗8)
20 C 21 C (∗7) 25 B 14 B (∗8)
27 28 20 A 21 A (∗4) 6 14 49 41 6 A 5 A (∗9)
CANH CANL CANH CANL CANH CANL CANL CANH CANH CANL
1 2 3 4
(BAT)
30A
H–LP MAIN
2
B
W
1
7 1
B
B
B B
W
BR
1 1 1 1
7 7 7 7
10A 10A 15A 15A
H–LP H–LP H–LP H–LP
HI LH HI RH LO LH LO RH 5 1 5 1
2 2 2 2 DIM H–LP
Relay Relay
7 7 1 1
3 2 3 2
GR
7 7 7 7
GR
GR
GR
B
B
V
B
8 AA2 5 BA1 4 BA1 2 BA1 7 BA1
B
B
G
BR
GR
GR
20 AD3 1 3 1 3
B B B B 16 4B 17 4B
GR
High
High
16 4C 4 4J 3 4J
YARIS (EM02C4EL)
Low (HID)
Low (HID)
Light
Control ECU
Light
Control ECU
14 F (∗3)
Y
14 D (∗1)
14 B (∗2)
HI HI 6
B17
Headlamp Assembly (LH)
B16
Headlamp Assembly (RH)
P
P
SB 1 D40
2 2 Junction
Connector
8
9 10
W–B
W–B
Beam
HU HL
GR
W–B
W–B
11 B (∗2) OFF Flash
6 BA1
P
Tail Low
Light
Control SW
Dimmer SW
Head High
Main Body ECU
< 25–10>
ED
D4 7
W–B
W–B
Headlamp Dimmer SW
Assembly
12 17
W–B W–B
4E 4E
B1 A1 D2
M
373
10 YARIS
374
H e a d lig h t (E x c e p t H ID T y p e )
1 2 3 4
(BAT) (BAT) ∗ 1 : w/ Theft Deterrent System
∗ 2 : w/o Theft Deterrent System
∗ 3 : From Jan. 2008 Production until Oct. 2009 Production
10A 10A ∗ 4 : Before Jan. 2008 Production
H–LP RH/ H–LP LH/
H–LP LO RH H–LP LO LH ∗ 5 : From Jan. 2009 Production
∗ 6 : Before Jan. 2009 Production
∗ 7 : From Oct. 2009 Production
2 2
1 1
GR(∗5)
GR
GR(∗2 ∗6) (∗1)
GR
GR(∗1 ∗6)
B
L
GR
(∗1)
(∗1)
GR
GR
(∗6)
3 3
5 1
B4 B6
20 AD3 Headlamp (RH) Headlamp (LH)
H–LP/AMT
2 1 2 1 Relay
BR
GR
3 2
G
L
14 F (∗7)
14 D (∗3) 2 2
14 B (∗4) 7 BA1 4 BA1 2 BA1 5 BA1
L
V
GR
(∗1)
(∗1)
(∗1)
L V
W–B
(∗1 ∗6)
(∗1) (∗1)
L
V
Beam
BR
(∗2)
(∗2)
V
(∗1)
YARIS (EM02C4EL)
16 4C 4 4J 3 4J
M OVERALL ELECTRICAL WIRING DIAGRAM
P
SB
P
9 A 8 A (LHD)
Y
9 B 10 B (RHD)
HU HL
6
1 D40
Junction
B1 T1 RF H ED HU HL (H) ED Connector
8
OFF Flash
GR
(∗1)
Tail Low
Light
Control SW
Dimmer SW
Head High
12 17
W–B W–B
4E 4E
D2 A1
11 YARIS
H e a d lig h t B e a m L e v e l C o n tro l
1 2 3 4
(BAT)
A28
Fusible
Link Block
120A ALT
1
B
1 4G
T–LP
Relay
GR
10A LG
R
R
TAIL
11 A 10 A 9 A 7 A
A24(A) A24(A), B13(B)
Junction Connector Junction 15 AA2 16 AA2
9 4S 33 4B Connector
12 A
R
LG
P
10 B 12 B 9 B 11 B
6 AD3 5 AD3
R
R
R
G
G
LG
YARIS (EM02C4EL)
3 2 3 2 2 1
LH T LHM+ RH T RHM+ T B
LH E RH E E
B15
Headlamp Leveling Motor (LH)
B14
Headlamp Leveling Motor (RH)
D52
Headlamp Leveling SW
1 1 4
W–B
W–B
W–B
W–B 7 AD3
W–B
W–B
W–B
9 BA1 10 AA2
W–B
B1
M
375
12 YARIS
376
T u rn S ig n a l a n d H a z a rd W a rn in g L ig h t (L H D )
1 2 3 4
(BAT) (IG)
∗ 1 : From Jan. 2008 Production until Oct. 2009 Production
∗ 2 : Before Jan. 2008 Production
10A 10A ∗ 3 : From Jan. 2009 Production
HAZ GAUGE ∗ 4 : Before Jan. 2009 Production
∗ 5 : Outer Rear View Mirror Type
∗ 6 : Front Fender Type
2 ∗ 7 : From Oct. 2009 Production
D4
1 Headlamp Dimmer SW Assembly
E TR TL
R
RH
1
N
Turn
Signal SW
IG
LH
FLASHER Relay
+B LR LL EHW GND EL ER E TR TL
4 2 3 8 7 5 6 7 6 5
V
B
W–B
28 4E 12 4S 11 4S
32 4B 31 4B 14 4B 28 4A 27 4A 16 4S 13 4S 17 4S 17 4E
B
LG
BR
(∗5)
(∗5)
Y
LG
2 B 1 B 4 B 3 B 4
LG(∗6)
LG(∗5)
BR(∗6)
BR(∗5)
G
G
D7
LG
LG
(∗6)
(∗6)
Hazard Warning
YARIS (EM02C4EL)
Signal SW
4 A 3 A 1 A 2 A
M OVERALL ELECTRICAL WIRING DIAGRAM
D34(A), D35(B)
Junction Connector
10 A 8 A 1
15 F 8 F (∗7)
B
R
(∗5)
(∗5)
W–B
15 D 8 D (∗1)
A24(A), B13(B)
Junction Connector
3 B 5 B 15 B 8 B (∗2)
13 FD2 13 GD2
G
LG
G
LG
(∗6)
(∗6)
2 B (∗4) 2 B (∗4) 5 5
G
G
(∗5)
(∗5)
1 1
W–B
Turn LH
Turn RH
1 C (∗3) 1 C (∗3)
W–B
Turn
Turn
10 10
B1(B), B18(C)
Turn Signal Lamp
(Front RH)
B8(B), B24(C)
Turn Signal Lamp
(Front LH)
A2
Turn Signal Lamp (Front Side LH)
A1
Turn Signal Lamp (Front Side RH)
1 B (∗4) 1 B (∗4) 2 2 TRNR TRNL
J3
Rear Combination Lamp (RH)
J4
Rear Combination Lamp (LH)
2 C (∗3) 2 C (∗3) 5
4 4 D40
Junction
GND GND Connector
D1(A), (C), (E), D2(B), (D), (F)
Combination Meter
F9
Outer Rear
View Mirror (RH)
G9
Outer Rear
View Mirror (LH)
(∗6)
(∗6)
W–B
W–B
W–B
W–B
24 E (∗7) 6 6 11
24 A (∗2)
24 C (∗1)
(∗5)
(∗5)
W–B
W–B
W–B
W–B
8
W–B W–B
BA1
W–B
W–B
3 5A 5 5A
BR
4 6B 4 5B
W–B
W–B
B1 A1 J1 J2 D3 D2 D1 D1 D2
13 YARIS
T u rn S ig n a l a n d H a z a rd W a rn in g L ig h t (R H D )
1 2 3 4
(BAT) (IG) ∗ 1 : HID Type
∗ 2 : Except HID Type
∗ 3 : From Jan. 2008 Production until Oct. 2009 Production
10A 10A ∗ 4 : Before Jan. 2008 Production
HAZ GAUGE ∗ 5 : From Jan. 2009 Production
∗ 6 : Before Jan. 2009 Production
∗ 7 : Outer Rear View Mirror Type
2 D4
∗ 8 : Front Fender Type Headlamp Dimmer SW Assembly
∗ 9 : From Oct. 2009 Production
1 1 4R
L
E TR TL
R
RH
1 Turn N
Signal SW
IG
LH
D71
Turn Signal Flasher
B LR LL HAZ E EL ER E TR TL
4 2 3 8 7 5 6 11 13 12
B
Y
P
V
B
R
G
LG
W–B
W–B
4 4R 2 4R 3 4R 8 4R 7 4R 5 4R 6 4R 28 4E 12 4S 11 4S
32 4B 31 4B 14 4B 28 4A 27 4A 16 4S 13 4S 17 4S 17 4E
LG
BR
(∗7)
(∗7)
Y
B
LG
G
G
LG
LG
(∗8)
(∗8)
2 B 1 B 4 B 3 B 4
LG(∗8)
LG(∗7)
BR(∗8)
BR(∗7)
D7
4 A 3 A 1 A 2 A Hazard Warning
YARIS (EM02C4EL)
Signal SW
D34(A), D35(B)
Junction Connector
10 A 8 A 1
A24(A), B13(B)
Junction Connector
3 B 5 B 15 F 8 F (∗9)
B
R
(∗7)
(∗7)
15 D 8 D (∗3)
W–B
15 B 8 B (∗4)
G
LG
13 FD2 13 GD2
1 A (∗1) 1 A (∗1)
G
2 B (∗2 ∗6) 2 B (∗2 ∗6)
LG
(∗8)
(∗8)
2 D (∗5) 2 D (∗5) 5 5
G
G
(∗7)
(∗7)
1 1
Turn LH
Turn RH
W–B
W–B
A2
Turn Signal Lamp (Front Side LH)
A1
Turn Signal Lamp (Front Side RH)
1 B (∗2 ∗6) 1 B (∗2 ∗6) 2 2 TRNR TRNL
J3
Rear Combination Lamp (RH)
J4
Rear Combination Lamp (LH)
1 D (∗5) 1 D (∗5) 5
4 4 D40
Junction
GND GND Connector
D1(A), (C), (E), D2(B), (D), (F)
Combination Meter
F9
Outer Rear
View Mirror (RH)
G9
Outer Rear
View Mirror (LH)
(∗8)
(∗8)
W–B
W–B
W–B
W–B
24 E (∗9) 6 6 11
24 C (∗3)
24 A (∗4)
(∗7)
(∗7)
W–B
W–B
W–B
W–B
8
W–B W–B
BA1
W–B
W–B
1 5A 5 5A
BR
4 6B 4 5B
W–B
W–B
B1 A1 J1 J2 D3 D2 D1 D1 D2
M
377
14 YARIS (Cont. next page)
378
In te rio r L ig h t
1 2 3 4
(BAT) ∗ 1 : w/o Smart Entry & Start System
∗ 5 : From Jan. 2009 Production
∗ 6 : Before Jan. 2009 Production
15A ∗ 7 : Before Oct. 2009 Production
DOME ∗ 8 : From Oct. 2009 Production
L
13 4B D33(A), (E), D64(B), (F), D65(C), D66(D)
Main Body ECU
5 4K 4 4P
L
L
7 4A 2 4K 1 4K 17 4E 6 4C 21 4A 24 4A 2 4C 20 4A 5 4A
BR
SB
1 B
6 B 5 B
L
L
P
B
Y
(∗1)
W–B
W–B
D38(A), D39(B)
Junction
Connector
1 10 A 12 MJ1
J28(A), J29(B)
Junction
Connector
GR
2 A
L
L
L
R
R
G
1
(LHD)
(LHD)
(RHD)
(RHD)
12 JD1
W
BR
Transponder
Key ECU< 34–3>
GR
On
Off
Door
2 15 MN1
YARIS (EM02C4EL)
1
K1
Map Lamp
K2
Room Lamp (Center)
1 A (∗7) 1 A (∗7) 1 A (∗7) 1 A (∗7)
M OVERALL ELECTRICAL WIRING DIAGRAM
2 3 2
1 B (∗8) 1 B (∗8) 1 1 B (∗8) 1 B (∗8)
J12
Room Lamp (Luggage)
J30
Diode (Room Lamp)
2 1
P
BR
W–B
W–B
BE
(∗5)
J1(A), (B)
Door Courtesy SW
(Front RH)
J2(A), (B)
Door Courtesy SW
(Front LH)
D21
Parking Brake SW
J32(A), (B)
Door Courtesy SW (Rear RH)
J33(A), (B)
Door Courtesy SW (Rear LH)
O
(∗6)
W–B
2
Courtesy
N2
Back Door
Lock Assembly
1
W–B
W–B
N1 D2
14 YARIS (Cont' d)
In te rio r L ig h t S e a t B e lt W a rn in g
5 6 7 8
(ACC) (BAT) (BAT) ∗ 1 : w/o Smart Entry & Start System (IG) (BAT)
∗ 2 : w/ Smart Entry & Start System
∗ 3 : From Jan. 2008 Production
7. 5A 25A 7. 5A ∗ 4 : Before Jan. 2008 Production 7. 5A 15A
ACC D/L ECU–B ∗ 5 : From Jan. 2009 Production MET AM2
∗ 6 : Before Jan. 2009 Production
∗ 8 : From Oct. 2009 Production
2 ∗ 9 : From Jan. 2008 Production until Oct. 2009 Production 2
1 1 4M 1 1B
16 25
L L L
AA2 AA2
(LHD)(RHD)
30 4B 2 4S
B
GR
(∗2)
(∗1)
D33(A), (E), D64(B), (F), D65(C), D66(D)
21 4 Main Body ECU 6
ACC ALTB ECUB(∗1) 2 E 1 E (∗8)
2 C 1 C (∗9)
2 A 1 A (∗4)
SWIL GND2 CANH CANL LSR LSWP LSWD DBKL AM1 AM2
23 E 22 E 24 E 5 E 21 E 9E (∗1 ∗3) 1 C 6 F (∗3)
23 A 22 A 24 A 5 A 21 A 9A (∗1 ∗4) 6 B (∗4)
8 C 4 C 15 D 16 D 10 D (∗2) 10 F 25 F 26F (∗2 ∗3)
10 B 25 B 26B (∗2 ∗4)
BE
SB
(∗2)
W
(∗2 ∗5)
(∗2 ∗6)
Door Driver' s 4 AD2
Seat Belt
5 JD1
LED Driver
6 A 7 A
D36(A)
Junction
Connector
GR
(∗2)
5 A
CPU
W
W
(LHD)
(RHD)
D1(A), (C), (E)
Combination Meter
W–B
GR
(∗2)
2 2
Multiplex Communication
System (CAN)< 8–1>
+ +
CAN I/F
E E
J34
Front Seat
Inner Belt (RH)
J35
Front Seat
Inner Belt (LH)
1 1
YARIS (EM02C4EL)
21 E 20 E 24 E (∗8)
21 C 20 C 24 C (∗9)
21 A 20 A 24 A (∗4)
W–B
W–B
(LHD)
(RHD)
17
W–B
JD1
BR
W–B
W–B
15 4A 1 4S
Multiplex Communication
System (CAN)< 8–2>
17 4E 7 4M
W–B
W–B
W–B
W–B
1 5A (LHD)
4 5A (RHD)
D1 D2 D2 D1 D3
M
379
15 YARIS (Cont. next page)
380
∗ 1 : w/ Theft Deterrent System
∗ 2 : w/o Theft Deterrent System
T a illig h t a n d Illu m in a tio n ∗ 9 : From Jan. 2009 Production
∗10 : Before Jan. 2009 Production
1 2 3 4
(BAT)
A28
Fusible
Link Block
120A ALT
(∗2) (∗1)
1 A
(∗1)
(∗1)
10A
B
10A TAIL (∗1)
TAIL 7. 5A
Main Body ECU PANEL2
< 24–10> < 25–10> (∗2)
T–LP Relay
(∗1)
(∗1) (∗1)
(∗2)
(∗1)
1 4G 4 4M 9 4S 10 4E 33 4B 10 4A 15 4B 29 4A
W
W
(∗2)
(∗1)
(∗2)
P
G
G
GR
12 A Engine ECU
< 6–8>
A24(A), B13(B)
Junction
Connector
13 A (LHD) 7 B 8 B
5 B (RHD) G
B1
B1 T1
G
G
G
G
Light OFF
G
Control
(HID Type)
(HID Type)
SW Tail
YARIS (EM02C4EL)
(Except HID Type)
(Except HID Type)
M OVERALL ELECTRICAL WIRING DIAGRAM
Head
4 2 A (∗10) 2 A (∗10) 4 1 1
D4(A), (B)
Headlamp Dimmer SW Assembly
T1 1 B (LHD ∗9) 1 B (LHD ∗9)
B B
10 A (LHD) 2 C (RHD ∗9) 2 C (RHD ∗9) 2
8 B (RHD)
Tail
Tail
J38
License Plate Lamp
Clearance
Clearance
G 1 A (∗10) 1 A (∗10) 1
(∗2) HI 2 B (LHD ∗9) 2 B (LHD ∗9) HI
B16
Headlamp Assembly (RH)
B3(A), B22(B), B23(C)
Clearance Lamp (RH)
B7(A), B20(B), B21(C)
Clearance Lamp (LH)
B17
Headlamp Assembly (LH)
J3
Rear Combination Lamp (RH)
J4
Rear Combination Lamp (LH)
W–B
W–B
(∗1 LHD)
(∗1 RHD)
W–B
W–B
W–B
W–B
(HID Type)
(HID Type)
W–B
4 5A
W–B
W–B
4 6A
D1 D2 B1 J1 J2
15 YARIS (Cont' d)
5 6 7 8
10 4P
∗ 3 : w/ Smart Entry & Start System
∗ 4 : w/ Rear Fog Light
A ∗ 5 : Before Jan. 2007 Production
∗ 6 : From Jan. 2007 Production until Jan. 2008 Production
∗ 7 : From Jan. 2008 Production until Oct. 2009 Production
∗ 8 : Before Jan. 2008 Production
∗ 9 : From Jan. 2009 Production
∗10 : Before Jan. 2009 Production
∗11 : From Jan. 2008 Production until Jan. 2009 Production
7. 5A ∗12 : From Oct. 2009 Production
PANEL1
V
8 4P 7 4Q 7 4P 2 4Q R
8 B 9 B
G(∗9)
Y
V
5
G(∗10) G
D38(A), D39(B)
Junction Connector
DE1
(∗10) 2 A 3 A
3 G
(∗4) 20 A (∗10) E10(A), D88(B)
R
G
G
G
(∗3)
Junction Connector
(A/T)
20 B (∗9)
D52
Headlamp Leveling SW
Front Fog
Light Relay
< 17–1>
4
19 A 21 A 22 A (∗10)
19 B 21 B 22 B (∗9) 3
G
L
B
W–B
GR
Rear Fog
Light Relay
< 17–3>
2 A (∗10) 5 A (∗5)
7 AD3 2 B (∗9) 5 B (∗6)
ILL+ 5 C (∗11) 5 A (∗10)
Main Body ECU
< 2–18>
W–B
16 B 14 A (∗8)
YARIS (EM02C4EL)
E GND
E1(A), D93(B)
Blower SW
E6(A), (B), (C), D98(D)
Rear Window
Defogger SW
E5(A), D97(B)
A/C SW
D7
Hazard Warning Signal SW
D20
A/T Shift Lever Illumination
D10
Radio Receiver Assembly
Illumination I/F
W–B
(A/T)
Tail
4 D (∗9)
W–B
W W
W
CPU
9 BA1
10 A 8 A (∗10) 20 B 19 B
(∗9)
W–B
W–B
W–B
10 B 8 B (∗9)
(LHD ∗10)
(RHD ∗10)
(∗9)
(∗10)
24 E (∗12)
24 C (∗7) E10(A), D88(B) 9 A (∗10)
24 A (∗8) Junction 9 B (∗9) D36(A), D37(B) 15 A
2 ED1 1 DE2 Connector Junction
Connector
W–B
R
(∗10)
W–B
W–B
(LHD ∗10)
(RHD ∗10)
8 DE1
BR
W–B
W–B
W–B
W–B
W–B
(LHD ∗9)
(RHD ∗9)
B1 D3 D1 D2 D1 D2 D1 D3
M
381
16 YARIS
382
B a c k – U p L ig h t S to p L ig h t
1 2 3 4
(IG) (BAT) ∗ 1 : w/ Smart Entry & Start System
∗ 2 : From Jan. 2009 Production
∗ 3 : Before Jan. 2009 Production
10A 10A ∗ 4 : LED Type
GAUGE STOP ∗ 5 : Bulb Type
19 4B 18 4B
G
B
1 CA1 2
A13
Stop Lamp SW
1
G Engine ECU
< 6–6> BE
(∗2)
G
G
O
(A/T)
(M/T)
12 4B (∗3)
2 2
C22 21 18
Skid Control ECU G G Shift Control 10 MJ1
Back–Up Lamp SW RB RL with Actuator 4B 4S
J28(A), J29(B) ECU< 27–4>
< 19–2> < 36–2>
9 B Junction Connector
R 24
Main Body ECU G
C27
Park/Neutral Position SW
4E 1
1 1 < 2–4> (∗1)
O
BE
(∗2)
(∗3)
12 4A
M1
Center Stop Lamp
10 A 9 A
R
V
(A/T)
2
J28(A), J29(B)
R 3 B Junction Connector 4 B
(A/T)
R
(M/T)
R
R
BR
3 A 4 A
YARIS (EM02C4EL)
(A/T)
M OVERALL ELECTRICAL WIRING DIAGRAM
30 4A 3 3
V
O
BE
(∗2)
(∗3)
Back–Up
Back–Up
J3
Rear Combination Lamp (RH)
J4
Rear Combination Lamp (LH)
Engine ECU
< 6–17>
3 CA1 2 2
4 4
W–B
22 4B
(∗4)
(∗5)
(∗4)
(∗5)
Stop
Stop
R
Stop
Stop
11 MJ1
(∗4)
(∗5)
(∗4)
(∗5)
W–B
W–B
J4
Rear Combination Lamp (LH)
J3
Rear Combination Lamp (RH)
4 4
W–B
W–B
W–B
8 7
W–B B W–B W–B
MN1 MJ1
W–B
W–B
J1 J2 N1 J2 J1
17 YARIS
F ro n t F o g L ig h t R e a r F o g L ig h t
1 2 3 4
(BAT) (BAT)
∗ 1 : w/ Front Fog Light
∗ 2 : w/ Rear Fog Light
15A ∗ 3 : From Jan. 2008 Production until Oct. 2009 Production 7. 5A
FR FOG ∗ 4 : Before Jan. 2008 Production RR FOG
∗ 5 : From Oct. 2009 Production
9 4M 2 4M
V
R
(∗1)
PANEL1 Fuse G
< 15–6>
PANEL1 Fuse
< 15–5>
V
D4(A), (B) 3 A (LHD)
Headlamp Dimmer SW Assembly 2 5 2 B (RHD) 2 5
D46
Front Fog Light Relay BFG D72
Rear Fog Light Relay
LFG BFG BFG LFG B
OFF 1 3 OFF 1 3
R
SB
Front Front (∗1)
Fog Light SW
Fog Light SW
Rear (∗2) Rear
R
R
R
Y
SB
SB
SB
W–B
W–B
(LHD)
(RHD)
A24(A), B13(B)
6 A Junction Connector
7 F (∗5)
7 D (∗3)
7 B (∗4) 6 F (∗5)
YARIS (EM02C4EL)
6 D (∗3)
5 2 B 1 B 5 6 B (∗4) 6 6
D40 D40
Junction Junction Connector
Connector
11 11
Front Fog
Rear Fog
Rear Fog
R
R
Rear Fog
24 E (∗5) 4 4
D1(A), (C), (E), D2(B), (D), (F)
Combination Meter
24 C (∗3) 24 E (∗5)
24 A (∗4) 2 2 24 A (∗3)
B10 B9 24 A (∗4)
Fog Lamp Fog Lamp
1 (Front LH) 1 (Front RH)
W–B
BR
W–B
W–B
W–B
(LHD)
(RHD)
BR
W–B
W–B
D1 D3 B1 D1 D3 J1 J2
M
383
18 YARIS
384
L ig h t R e m in d e r K e y R e m in d e r (w /o S m a rt E n try & S ta rt S y s te m )
1 2 3 4
(IG) (BAT)
7. 5A 7. 5A
MET ECU–B
1 4M 1
∗ 1 : w/ Smart Entry & Start System
∗ 2 : w/o Smart Entry & Start System
L
B
∗ 3 : w/ Theft Deterrent System
∗ 4 : From Jan. 2008 Production
∗ 5 : Before Jan. 2008 Production
∗ 6 : From Jan. 2009 Production
∗ 7 : Before Jan. 2009 Production
16 AA2 (LHD)
∗ 8 : From Jan. 2008 Production until Oct. 2009 Production
25 AA2 (RHD)
∗ 9 : From Oct. 2009 Production
14 E 1 E 2 E (∗9) 2 4S 30 4B
14 C 1 C 2 C (∗8)
14 A 1 A 2 A (∗5) D33(A), (E), D66(D)
Main Body ECU 6
ECUB
YARIS (EM02C4EL)
CPU
M OVERALL ELECTRICAL WIRING DIAGRAM
CAN Controller
Y
Y
O
BE
(∗3)
(∗6)
(∗7)
Buzzer
D19
Unlock Warning SW
Combination Meter
Interior Light System
< 14–3>
20 C 21 C 24 C (∗8)
20 A 21 A 24 A (∗5)
Theft Warning ECU
< 24–11> < 25–11>
Transponder
Key ECU< 34–3>
BR
W–B
W–B
Multiplex 1 6A (LHD)
Communication
System (CAN)< 8–2> 3 6A (RHD)
D3 D2
19 YARIS
∗ 1 : From Jan. 2008 Production
∗ 2 : Before Jan. 2008 Production
A B S (B e fo re O c t. 2 0 0 9 P ro d u c tio n ) ∗ 3 : From Jan. 2009 Production
∗ 4 : Before Jan. 2009 Production
1 2 3 4
(IG) (IG) (BAT) (BAT)
2 2
1 4M 24 4B 1 1
B
4 A (RHD)
16 B (LHD)
B
B
1 A (∗2)
(LHD, RHD ∗3)
(LHD, RHD ∗3)
B
(RHD ∗4)
P
V
B
R
G
W
(RHD ∗4)
(RHD ∗4)
B
1 AA1
ABS
(LHD, RHD ∗3)
Brake
B
Display LED Driver
(RHD ∗4)
25 9 8 31 30 1 23
IG1 FL+ FL– FR+ FR– +BS +BM
CPU A15
Skid Control ECU with Actuator
CAN Controller
SP1 STP CANL CANH RL– RL+ RR– RR+ GND1 GND2
26 10 5 6 12 11 34 33 2 24
YARIS (EM02C4EL)
CAN I/F I/F
D1(A), (C)
Combination Meter
L
P
B
Y
G
LG
W–B
W–B
24 C 21 C 20 C 17 C (∗1)
24 A 21 A 20 A 17 A (∗2)
11 AD3
11 AJ1 10 AJ1 9 AJ1 8 AJ1
L
P
B
Y
LG
BR
Stop Lamp SW
< 16–3>
BR
BR
Multiplex
Communication
System (CAN)< 8–2>
W–B
1 2 1 2
a1 Z1
Speed Sensor Speed Sensor
(Rear LH) (Rear RH)
D3 A2
M
385
20 YARIS
386
∗ 1 : From Jan. 2008 Production until Oct. 2009 Production
SRS ∗ 2 : Before Jan. 2008 Production
∗ 3 : From Oct. 2009 Production
1 2 3 4
(IG) (IG)
D1(A), (C), (E)
Combination Meter
7. 5A 7. 5A
IGN MET
16 4E 1 4M
SRS
LED Driver
A6 A12
Airbag Sensor Airbag Sensor CPU
(Front RH) (Front LH)
CAN Controller
B
+SR –SR +SL –SL
2 1 2 1 CAN I/F
B
B
B
W
W
1 E 21 E 20 E 24 E (∗3)
1 C 21 C 20 C 24 C (∗1)
1 A 21 A 20 A 24 A (∗2)
DLC3< 7–3>
1 AD1 2 AD1 3 AD1 4 AD1
BR
B
B
W
W
W
D16(A), J8(B), J9(C)
16 A 21 A 29 A 27 A 30 A 28 A Airbag Sensor Assembly Center
Multiplex
Communication
System (CAN)
< 8–2>
YARIS (EM02C4EL)
E2 E1 PP+ PP– PD+ PD– (RHD) P+ P– D+ D– CANL CANH
M OVERALL ELECTRICAL WIRING DIAGRAM
26 A 25 A 2 B 1 B 4 C 5 C (LHD) 4 A 3 A 5 A 6 A 22 A 13 A
4 C 5 C 2 B 1 B (RHD)
W–B
W–B
Y
Y
Y
Y
Y–B
Y–B
Y–B
Y–B
14 4E 30 4E
1 DQ2 2 DQ2
1 A 2 A
D+ D–
7 4M 17 4E
Y–R
Y–G
D18(A), W1(B)
Spiral Cable
Multiplex
Communication
System (CAN)< 8–4>
2 1 2 1 2 1 2 B 1 B
BR
W–B
W–B
J21 J20 Q1 W1(B)
Pretensioner Pretensioner Airbag Squib Airbag Squib
1 5A (LHD) (LH) (RH) (Front Passenger' s (Steering Wheel Pad)
Airbag Assembly)
4 5A (RHD)
D1 D2 D3
21 YARIS
EPS
1 2 3 4
(IG) (BAT) (IG)
7. 5A 50A 10A
MET EPS ECU–IG ∗ 1 : RHD, LHD Before Jan. 2008 Production
∗ 2 : LHD From Jan. 2008 Production
∗ 3 : From Jan. 2008 Production
2 ∗ 4 : Before Jan. 2008 Production
∗ 5 : From Jan. 2008 Production until Oct. 2009 Production
1 4M 1 7 4S
∗ 6 : From Oct. 2009 Production
B
R
W
c1(D)
Power Steering Torque Sensor
1 E (∗6) 8 B
D36(A), D37(B)
Junction Connector
1 A
M
L
P
LG
B
Y
B
R
R
W
P/S
b1(C)
1 A (∗1) 6 F 2 F 11 F (∗3) Power Steering Motor
1 E (∗2) 6 B 2 B 11 B (∗4) 1 C 2 C 6 D 5 D 7 D 8 D
LED Driver
PIG IG SIL TS M1 M2 TRQV TRQ1 TRQ2 TRQG
CPU
CANH CANL SPD PGND
CAN Controller
1 F 7 F (∗3) A19(A), (E), D31(B), (F), b1(C), c1(D) 5 F (∗3) 2 A (∗1)
1 B 7 B (∗4) Power Steering ECU 2 E (∗2)
YARIS (EM02C4EL)
CAN I/F
21 E 20 E 24 E (∗6)
21 C 20 C 24 C (∗5)
21 A 20 A 24 A (∗4)
BR
W–B
Combination
Meter< 31–2>
Multiplex Communication
System (CAN)< 8–1> < 8–2>
Multiplex Communication
System (CAN)< 8–2>
D3 A3
M
387
22 YARIS (Cont. next page)
388
P o w e r W in d o w (L H D )
1 2 3 4
G1
(BAT) (BAT) (IG) Power Window Master SW
A28
7. 5A Fusible Link Block 10A
ECU–B ECU–IG
120A ALT
B U D
2
1 6 16 15
1
B
P
GR
1 4G
L
PWR
Relay
GR
21 4A
L
6 D33(A), (E) 4 E (∗1)
Main Body ECU 4 A (∗2)
17 4E 1 4A 19 4A 2 4H 11 4H 30 4B
L
L
P
SB
SB
BR
GR
W–B
BR
A
YARIS (EM02C4EL)
SB
B
M OVERALL ELECTRICAL WIRING DIAGRAM
SB
C
L
F1
Power Window SW
(Front RH)
Up
Down
4 1
R
G
W–B
2 1
M
D2 F4
Power Window Regulator Motor
(Front RH)
22 YARIS (Cont' d)
P o w e r W in d o w (L H D )
5 6 7 8
G1
Power Window Master SW
U D U D E U D LED+ AUTO
12 13 10 18 1 8 5 3 4
Y
B
R
G
W–B
R
R
G
W
8 GD2 9 GD2 17 GD2 18 GD2 (BAT) 10 7 5 4
U D LED AUTO G8
20A Power Window Regulator Motor
D DOOR (Front LH)
+B S1 E
2 9 1
Y
B
R
G
10 4H
LG
BR
11 JD1 10 JD1 2 JD1 1 JD1 W–B
1 GD2 12 GD2
LG
Y
B
R
G
BR
2 IJ1 3 IJ1 2 HJ1 3 HJ1
R
R
G
G
BR
A
YARIS (EM02C4EL)
SB
B
SB
C
SB
SB
1 IJ1 5 1 1 HJ1 5 1
SB 3 SB 3
W–B
W–B
Up
Up
Down
Down
I1
Power Window SW (Rear LH)
H1
Power Window SW (Rear RH)
4 2 4 2
Y
B
Y
B
3 5B 6 5B
1 2 1 2
M M
I2 H2 D1
Power Window Regulator Power Window Regulator
Motor (Rear LH) Motor (Rear RH)
M
389
23 YARIS (Cont. next page)
390
P o w e r W in d o w (R H D )
1 2 3 4
F7
(BAT) (BAT) (IG) (BAT) Power Window Master SW
A28
7. 5A Fusible Link Block 10A 15A
ECU–B ECU–IG AM2
120A ALT
B U D
2 2
1 6 12 13
1 1 1B
B
GR
(∗1)
P
W
∗ 1 : w/ Smart Entry & Start System
GR
∗ 2 : w/o Smart Entry & Start System
4 AD2
∗ 3 : From Jan. 2008 Production
1 4G
∗ 4 : Before Jan. 2008 Production
2 FD2 11 FD2 10 FD2
∗ 5 : From Jan. 2009 Production
GR
(∗1)
∗ 6 : Before Jan. 2009 Production
∗ 7 : Before Oct. 2009 Production
6 A 5 A
L
∗ 8 : From Oct. 2009 Production
(∗2)
PWR
BE
Relay
(∗1 ∗5)
(∗1 ∗6)
D36(A)
Junction
Connector
P
SB
(∗1)
21 4A
11 GD2 10 GD2
25 AA2 1 6 F (∗3)
1 13 26 5 1 C 6 B (∗4)
20A 20A GND1 PWS DCTY IG AM1 AM2
30A
RL RR POWER
DOOR DOOR
LIN2(∗8)
ECUB CANP(∗7)
2
L
(∗2)
6 D33(A), (E), D64(B), (F), D65(C) 23 F (∗1 ∗3)
Main Body ECU 23 B (∗1 ∗4)
4 E (∗2 ∗3)
17 4E 1 4A 19 4A 2 4H 11 4H 30 4B 4 A (∗2 ∗4)
L
L
P
SB
SB
BR
GR
(∗2)
W–B
BR
A
YARIS (EM02C4EL)
SB
B
M OVERALL ELECTRICAL WIRING DIAGRAM
SB
C
L
2 GD2 5 2
L 3
G7
Power Window SW
(Front LH)
Up
Down
4 1
R
G
W–B
2 1
M
D2 G4
Power Window Regulator Motor
(Front LH)
23 YARIS (Cont' d)
P o w e r W in d o w (R H D )
5 6 7 8
F7
Power Window Master SW
U D U D E U D LED+ AUTO
18 10 16 15 9 1 5 3 4
Y
B
R
G
W–B
R
R
G
W
8 FD2 9 FD2 17 FD2 18 FD2 (BAT) 10 7 5 4
U D LED AUTO F8
20A Power Window Regulator Motor
D DOOR (Front RH)
+B S1 E
2 9 1
Y
B
R
G
10 4H
LG
BR
11 JD1 10 JD1 2 JD1 1 JD1 W–B
1 FD2 12 FD2
LG
Y
B
R
G
BR
2 IJ1 3 IJ1 2 HJ1 3 HJ1
R
R
G
G
BR
A
YARIS (EM02C4EL)
SB
B
SB
C
SB
SB
1 IJ1 5 1 1 HJ1 5 1
SB 3 SB 3
W–B
W–B
Up
Up
Down
Down
I1
Power Window SW (Rear LH)
H1
Power Window SW (Rear RH)
4 2 4 2
Y
B
Y
B
3 6B 5 6B
1 2 1 2
M M
I2 H2 D2
Power Window Regulator Power Window Regulator
Motor (Rear LH) Motor (Rear RH)
M
391
24 YARIS (Cont. next page)
392
∗ 1 : From Jan. 2008 Production
∗ 2 : Before Jan. 2008 Production
D o o r L o c k C o n tro l (L H D ) ∗ 3 : From Jan. 2009 Production
∗ 4 : Before Jan. 2009 Production
1 2 3 4
D33(A), (E)
(BAT) (BAT) (IG) (ACC) Main Body ECU
7. 5A 25A 10A 7. 5A
ECU–B D/L ECU–IG ACC
ACC IG ALTB ECUB KSW DCTY PCTY RRCY BCTY GND1 HAZ LSWP UL2 L2 ACT– ACT+
2 21 5 4 6 9 26 20 22 23 1 25 5 E (∗1) 16 14 3 2
5 A (∗2)
1
A
FLASHER
Relay< 12–3>
30 4B 7 4D 21 4A 24 4A 20 4A 5 4A 7 4A 17 4E 15 4A 15 4H 16 4H 18 4H 8 4H
16
L L
AA2
L
P
O
O
G
(∗4)
(∗4)
W–B
W–B
BE(∗3)
BE(∗3)
Key Reminder
System< 18–4>
9 FD1 8 FD1 7 FD1 20 FD1 10 FD1
G
BR
(∗4)
BE(∗3)
7 5 6 1 4
LSSR UL L UL L
YARIS (EM02C4EL)
Key Lock
Unlock
Detection
Key Unlock
M OVERALL ELECTRICAL WIRING DIAGRAM
E
8 F5
Door Lock Assembly
(Front RH)
W–B
W–B
E
1 6B
D2 D2
24 YARIS (Cont' d) (Cont. next page)
∗ 1 : From Jan. 2008 Production ∗ 5 : Before Oct. 2009 Production
∗ 2 : Before Jan. 2008 Production ∗ 6 : From Oct. 2009 Production
D o o r L o c k C o n tro l (L H D ) ∗ 3 : From Jan. 2009 Production
∗ 4 : Before Jan. 2009 Production
5 6 7 8
D33(A), (E)
Main Body ECU
LIN2(∗6)
LSWD LSR CANP(∗5) L1 UL1 HORN CANL CANH
21 E (∗1) 24 E 4 E (∗1) 12 10 15 22 E 23 E (∗1)
21 A (∗2) N7 24 A 4 A (∗2) 22 A 23 A (∗2)
Back Door Lock
A Assembly
B
M
C
L
O
BE
(∗3)
(∗4)
D
3 4
HORN Relay
< 29–3>
P
6 4H 7 4H 9 4H 17 4H 3 4A 4 4A 4 4H 5 4H
GR
7 MN1 6 MN1 8 JD2
LG
BE
(∗3)
(∗4)
B
B
Multiplex Communication
System (CAN)< 8–1>
8 MJ1 9 MJ1
L
Y
W
SB
BR
5 GD1 6 GD1
GR
P
GR
J28(A), J29(B)
8 B 2 B Junction Connector 7 B 1 B
BE
(∗3)
(∗4)
9 GD1 8 GD1 7 GD1 20 GD1 10 GD1
O
BE
BR
(∗3)
(∗4)
2 9
11 A 5 A 12 A 6 A L UL
L
P
O
G
BR
(∗4)
O(∗4)
BE(∗3)
BE
(∗3)
P
P
O
BE
GR
GR
(∗3)
(∗4)
8 10 9 1 4
Lock
Unlock
LSSR UL L UL L
M 1
YARIS (EM02C4EL)
Key Lock
Unlock
Detection
Key Unlock
P
P
O
O
BE
BE
GR
GR
(∗4)
(∗3)
(∗4)
(∗3)
W–B
E 4 1 6 4 1 6
7 G5 L UL LSSR L UL LSSR
Door Lock Assembly
(Front LH) M M
Unlock
Detection
Unlock
Detection
E E
H3 9 I3 9
Door Lock Assembly Door Lock Assembly
(Rear RH) (Rear LH)
W–B
W–B
W–B
12 HJ1 12 IJ1
W–B
W–B
W–B
1 5B 3 5B
D1
M
393
24 YARIS (Cont' d)
394
W ire le s s D o o r L o c k C o n tro l
T h e ft D e te rre n t (L H D )
(L H D )
9 10 11 12
D33(A), (E)
Main Body ECU (BAT) (BAT) (IG)
15A 7. 5A 10A
DOME ECU–B ECU–IG
W–B W–B
W–B
PRG RDA SRX STX HRLY TRLY
17 E 16 E 18 E 19 E 3 E (∗1) 1
19 2 2
17 A 16 A 18 A 19 A 3 A (∗2) LSWE
W–B
1 1 7 4S
L
1 2
Unlock
Detection
L
W
GR
16 AA2 BD+
N7
Back Door
Lock Assembly
L
R
2
L
B
T–LP Relay
< 15–2>
A33
Engine Hood
Courtesy SW
A34
Security Horn
P
2 1
16 JD1 15 JD1 13 4B 30 4B
12 MN1
O
W
BE
(∗3)
(∗4)
8 B
P
4 4P 5 4P 12 4H
D37(B)
Junction Connector
9 B
R
O
W
BE
(∗3)
(∗4)
15 MJ1 16 AD5 15 AD5
L
B
P
H–LP/AMT Relay
(Except HID Type)< 10–3>
11 A
P
D36(A), D37(B)
Junction
Connector 16 JD2
GR
O
W
BE
(∗3)
(∗4)
3 B
3 2 1 B
BE
(∗3)
(∗4)
BR
PRG RDA
11 13 9 6 4 15
D38(A), D39(B)
Junction
Connector
8 A +B1 +B2 IG LSR(∗5) DSWH SH–
J13
Door Control
Receiver
GND +B LUG(∗6) D74
Theft Warning
1 5 ECU
BRK– BRK+ KSW E IND
25 24 7 16 29
L
P
Y
G
W–B
L
18
W–B
YARIS (EM02C4EL)
O
D35
Junction
Connector
M OVERALL ELECTRICAL WIRING DIAGRAM
(∗4) 16
LG
14 JD1 BE
(∗3) 2
L
D25
Security
Indicator Lamp
6
W–B
W–B
3 5A
J2 D1 A1 N1
Memo
396
∗ 1 : w/ Smart Entry & Start System
∗ 2 : w/o Smart Entry & Start System ∗ 6 : Before Jan. 2008 Production
D o o r L o c k C o n tro l (R H D ) ∗ 3 : w/ Theft Deterrent System ∗ 7 : From Jan. 2009 Production
∗ 5 : From Jan. 2008 Production ∗ 8 : Before Jan. 2009 Production
1 2 3 4
D33(A), (E), D64(B), (F), D65(C), D66(D)
(BAT) (BAT) (BAT) (IG) (ACC) Main Body ECU
15A
AM2
7. 5A
ECU–B
25A D/L
7. 5A ACC
10A ECU–IG
ACC IG ALTB ECUB AM1 AM2 KSW DCTY PCTY RRCY BCTY GND1 HAZ LSWP UL2 L2 ACT– ACT+
2 2 21 5 4 6 1 C 6 F (∗5) 9 26 20 22 23 1 25 10 F (∗1 ∗5) 16 14 3 2
6 B (∗6) 10 B (∗1 ∗6)
1 1B 1 5 E (∗2 ∗5)
A
5 A (∗2 ∗6)
BE
SB
B
GR
(∗1)
(∗1)
(∗1 ∗7)
(∗1 ∗8)
4 AD2
C
6 A 7 A D
Turn Signal
Flasher< 13–3>
30 4B 7 4D 21 4A 24 4A 20 4A 5 4A 7 4A 17 4E 15 4A 15 4H 16 4H 9 4H 17 4H
5 A D36(A)
Junction
Connector
25
L L
AA2
(∗2) (∗2)
L
Y
B
W
SB
(∗3)
(∗3)
W–B
W–B
(∗3 ∗2)
(∗3 ∗2)
GR
(∗1)
Key Reminder
System< 18–4>
9 GD1 8 GD1 7 GD1 20 GD1 10 GD1
G
BR
(∗3)
(∗8)
BE(∗7)
(∗3 ∗2)
(∗3 ∗2)
8 10 9 1 4
LSSR UL L UL L
YARIS (EM02C4EL)
Key Lock
Unlock
Detection
Key Unlock
M OVERALL ELECTRICAL WIRING DIAGRAM
E
7 G5
Door Lock Assembly
(Front LH)
(∗3)
W–B
W–B
E
(∗3)
1 5B
D2 D1
25 YARIS (Cont' d) (Cont. next page)
∗ 1 : w/ Smart Entry & Start System ∗ 6 : Before Jan. 2008 Production
∗ 2 : w/o Smart Entry & Start System ∗ 7 : From Jan. 2009 Production
∗ 3 : w/ Theft Deterrent System ∗ 8 : Before Jan. 2009 Production
D o o r L o c k C o n tro l (R H D ) ∗ 4 : w/o Theft Deterrent System ∗ 9 : Before Oct. 2009 Production
∗ 5 : From Jan. 2008 Production ∗10 : From Oct. 2009 Production
5 6 7 8
D33(A), (E), D64(B), (F), D65(C), D66(D)
Main Body ECU
LIN2(∗10)
LSWD LSR CANP(∗9) L1 UL1 HORN CANL CANH
25 F (∗1 ∗5) 10 D (∗1) 23 F (∗1 ∗5) 12 10 15 22 E 23 E (∗2 ∗5)
25 B (∗1 ∗6) 24 E (∗2 ∗5) 23 B (∗1 ∗6) 22 A 23 A (∗2 ∗6)
21 E (∗2 ∗5) 24 A (∗2 ∗6) 4 E (∗2 ∗5) 16 D 15 D (∗1)
A
21 A (∗2 ∗6) 4 A (∗2 ∗6)
B
M
C
L
O
BE
N3(A), N7(B)
Back Door Lock
Assembly
D
(∗3 ∗7)
(∗3 ∗8)
1 A 2 A (∗4)
HORN Relay
< 29–3>
3 B 4 B (∗3)
6 4H 7 4H 18 4H 8 4H 3 4A 4 4A 4 4H 5 4H
GR
7 MN1 6 MN1 8 JD2
O
LG
BE
(∗7)
(∗8)
B
B
8 MJ1 9 MJ1
L
P
O
G
BR
(∗8)
Power Window System
< 23–3>
BE(∗7)
P
GR
Multiplex Communication
System (CAN)< 8–1>
5 FD1 6 FD1
GR
J28(A), J29(B)
8 B 2 B Junction Connector 7 B 1 B
BE
(∗3 ∗7)
(∗3 ∗8)
9 FD1 8 FD1 7 FD1 20 FD1 10 FD1
O
BE
BR
(∗7)
(∗8)
11 A 5 A 12 A 6 A 2 8
O(∗3 ∗8)
L UL
L
P
O
G
BR
(∗8)
BE(∗7)
BE
(∗3 ∗7)
P
P
O
BE
GR
GR
(∗3 ∗7)
(∗3 ∗8)
7 5 6 1 4
Lock
Unlock
LSSR UL L UL L
M 9
YARIS (EM02C4EL)
Key Lock
Unlock
Detection
Key Unlock
P
P
BE
BE
GR
GR
(∗3 ∗7)
(∗3 ∗7)
W–B
O(∗3 ∗8)
O(∗3 ∗8)
E
F5 4 1 6 4 1 6
8
Door Lock Assembly L UL LSSR L UL LSSR
(Front RH)
M M
Unlock
Detection
Unlock
Detection
E E
H3 9 I3 9
Door Lock Assembly Door Lock Assembly
(Rear RH) (Rear LH)
W–B
(∗3)
(∗3)
W–B
W–B
12 HJ1 12 IJ1
(∗3)
(∗3)
W–B
W–B
1 6B 3 6B
D2
M
397
25 YARIS (Cont' d)
398
W ire le s s D o o r L o c k C o n tro l
(R H D w /o S m a rt E n try T h e ft D e te rre n t (R H D )
& S ta rt S y s te m )
9 10 11 12
D33(A), (E), D64(B), (F), D65(C), D66(D)
Main Body ECU (BAT) (BAT) (IG) W–B
(∗2)
15A 7. 5A 10A ∗ 1 : w/ Smart Entry & Start System
1 B
DOME ECU–B ECU–IG ∗ 2 : w/o Smart Entry & Start System
LSWE ∗ 5 : From Jan. 2008 Production
PRG RDA SRX STX HRLY TRLY
∗ 6 : Before Jan. 2008 Production
17 E 16 E 18 E 19 E (∗5) 3 E (∗2 ∗5) 19 2 2 ∗ 7 : From Jan. 2009 Production
17 A 16 A 18 A 19 A (∗6) 3 A (∗2 ∗6)
Unlock
Detection
∗ 8 : Before Jan. 2009 Production
20 F (∗1 ∗5) 1 1 7 4S
BD+ ∗ 9 : Before Oct. 2009 Production
20 B (∗1
N7(B)
Back Door
Lock Assembly
L
∗6) ∗10 : From Oct. 2009 Production
2 B
R
R
W
GR
(∗2)
W–B W–B
P
25 AA2
(∗2 ∗8)
(∗2)
BE(∗2 ∗7)
T–LP Relay
< 15–2>
L
12 MN1
W–B
13 4B 30 4B
P
(∗2)
8 B 1 2
L
15 MJ1
D37(B)
Junction Connector
9 B
H–LP Relay
(HID Type)< 9–4>
4 4P 5 4P 12 4H B
A33
Engine Hood
Courtesy SW
A34
Security Horn
2 1
P
(∗2)
H–LP/AMT Relay
(Except HID Type)< 10–3>
L
P
O
W
BE
(∗7)
(∗8)
16 JD2
1 B 11 A
B
GR
D36(A), D37(B)
Junction
Connector 16 AD5 15 AD5
D38(A), D39(B)
Junction
Connector
O
8 A 3 B
BE
(∗2 ∗7)
(∗2 ∗8)
O
W
BE
(∗7)
(∗8)
L
BR
11 13 9 6 4 15
+B1 +B2 IG LSR(∗9) DSWH SH– D74
L
LUG(∗10)
Theft Warning
ECU
BRK– BRK+ KSW E IND
16 JD1 15 JD1 14 JD1 25 24 7 16 29
O LG
L
Y
R
G
YARIS (EM02C4EL)
W–B
(∗2 ∗8)
2
M OVERALL ELECTRICAL WIRING DIAGRAM
3 2 5 BE
P(∗2)
P(∗1)
O(∗1 ∗8)
BE(∗1 ∗7)
PRG RDA +B (∗2 ∗7) 16 18
D35
Junction
Connector
D25
Security 17
Indicator Lamp
LG
(∗1)
GND
J13 1 6
Door Control Receiver
W–B
(∗1)
(∗2)
W–B
5
W–B 10 D40
W–B
Junction
Unlock Warning SW
< 18–4>
Connector
Certification ECU
< 2–15>
11
Certification ECU
< 2–15>
W–B
(∗2)
W–B
W–B
1 5A
W–B
(∗1)
(∗1)
W–B
J2 D1 D2 A1 N1
26 YARIS
F ro n t W ip e r a n d W a s h e r ∗ 1 : w/ INT Time SW
∗ 2 : w/o INT Time SW
1 2 3 4
(IG) (IG)
15A 20A
WSH WIP
2 4B
1 4H 36 4B
L
(RHD)
2
A26
L
Junction
(LHD)
Connector
3
L
Y
B
L
(RHD)
+1 +2
L
4 4E
+B INT1 INT2 +S +1 +2 B1
1
A5 MIST Washer SW
M Windshield
Washer Motor
OFF WF EW
5 AD2 2 AD2 25 4B
2
INT Off
Wiper SW
LO On
L
G
W
HI
3 A 5 A 1 A 2 A (LHD)
4 B 1 B 3 B 2 B (RHD)
+S INT1 INT2 B1 +2 +1 +S B
1 AD2
YARIS (EM02C4EL)
M
(∗1)
(∗2)
4 A (LHD) A9(A), (B)
W–B
2 4E
+B +S W E
Wiper Relay
+S +B WF EW
W–B
17 4E
1 D 2 D 3 C 2 C (LHD)
4 B 3 B 1 A 2 A (RHD)
W
G
W–B
W–B
B
D2 A1
M
399
27 YARIS
400
R e a r W ip e r a n d W a s h e r S h ift L o c k
1 2 3 4
(IG) (IG) (IG) (ACC)
D5(A), (C), D6(B), (D)
Windshield Wiper SW Assembly
15A 15A 10A D43(A), (B)
RR WIP WSH WR +1R EW GAUGE Fuse Block
7. 5A ACC2
Washer
3 A (LHD)
Off
25 4A 2 4B 2 4P 2 B (RHD)
On
W
On+Washer
L
5 D 7 C 2 C (LHD)
(RHD)
10 B 4 A 2 A (RHD)
4 MJ1 2
A26
L
L
Junction
B
R
(∗2)
W–B
(LHD)
Connector
18 JD1
L
(RHD)
P
O
1
BE
(∗1)
(∗5)
(∗6)
W
A4
M Rear Washer
Motor
6 MJ1 1 B 3 B 9 B 7 B 11 B 6 B (∗3)
2
1 A 3 A 9 A 7 A 11 A 6 A (∗4)
IG AT3 NSSD STP P2 ACC
L
L
D22(A), (B)
Shift Lock
Control ECU
L
12 A 8 A (∗4)
L
(∗2)
W–B
YARIS (EM02C4EL)
L
W
M OVERALL ELECTRICAL WIRING DIAGRAM
1
1 2
B L
N1
D13
Key Interlock
Solenoid
M Rear Wiper
Motor Assembly 2
12
W–B 5 D40
Junction
2 4E (∗2) Connector
11
∗ 1 : w/ Smart Entry & Start System
∗ 2 : w/o Smart Entry & Start System
∗ 3 : From Jan. 2008 Production
17 4E
∗ 4 : Before Jan. 2008 Production
∗ 5 : From Jan. 2009 Production
W–B
3 5A (LHD)
W–B
1 5A (RHD)
D2 D1
28 YARIS
C ig a re tte L ig h te r o r
R e m o te C o n tro l M irro r
P o w e r O u tle t
1 2 3 4
(ACC) (ACC)
7. 5A 13 B 15A
ACC D34(A), D35(B) ∗ 1 : w/ Retractor CIG
Junction Connector ∗ 2 : From Jan. 2009 Production
∗ 3 : Before Jan. 2009 Production
19 A
6 4S 3 4Q
GR
GR
D12
8 Outer Mirror SW
B
GR
W–B 7 E
Retractor SW
Cigarette Lighter or
Up
Operation
SW
Left
Left/
Up
Right
Down
Right/
Down
Power Outlet
E
MH MV 2
Select SW
HL HR VL VR M+ MF MR
5 2 4 3 6 10 9
W–B
BE
(∗2)
(∗3)
B
SB
SB
P
Y
LG
(∗1)
(∗1)
B
B
Connector
SB
SB
D38
Junction 11
3 A 5 A (∗3) 3 A 5 A (∗3) Connector
YARIS (EM02C4EL)
4 B 9 B (∗2) 4 B 9 B (∗2)
MH MV MH MV
M M 13 17 6 12 16 5
M M M M
L
G
W
LG
BR
(∗1)
(∗1)
(∗1)
W–B
MR MF M+ MR MF M+ 14 FD1 14 GD1
G2(A), G9(B)
Outer Rear View Mirror (LH)
F2(A), F9(B)
Outer Rear View Mirror (RH)
1 A 2 A 4 A (∗3) 1 A 2 A 4 A (∗3)
7 B 2 B 8 B (∗2) 7 B 2 B 8 B (∗2)
W
L
L
LG
LG
(∗1)
(∗1)
(∗1)
(∗1)
W
16 GD1 15 GD1 16 FD1 15 FD1
W–B
BE(∗1 ∗2)
LG
BR
(∗1)
(∗1)
(∗1)
O(∗1 ∗3)
4 6A (LHD) 3 5A (LHD)
5 6A (RHD) 1 5A (RHD)
D2 D1
M
401
29 YARIS
402
R e a r W in d o w D e fo g g e r H o rn
1 2 3 4
(BAT) (IG) (IG) (BAT)
10A GAUGE
∗ 3 : From Jan. 2008 Production
2 ∗ 4 : Before Jan. 2008 Production 2
∗ 5 : From Jan. 2009 Production
∗ 6 : Before Jan. 2009 Production
∗ 7 : From Jan. 2008 Production
DEF until Jan. 2009 Production
Relay
HORN
Relay
2 4F 12 4Q 10 4S
10A O 7 1A 8 1A
ID/UP
B
(∗6)
B
BE
(∗6)
(∗5)
12 DE1
15
G
11 4M 20 JD2
LG
D88
15 DE1 Junction
B
O
(∗5)
(∗6)
Connector
B
15
V
17 E10
Junction 28 4B 17 AA2
Connector
B
P
(∗6)
(∗5)
17 Main Body ECU
P < 24–8> < 25–8>
(∗6)
G
18 4E
2 A 3 A (∗1)
B
B
2 B 3 B (∗2)
E6(A), (B), (C), D98(D) 2 C 3 C (∗7)
Rear Window Defogger SW 2 D 3 D (∗5)
RDEF IG+ 1 BA1
2 AD4 (LHD, RHD ∗5) 1 MJ1
8 AD3 (RHD ∗6)
B
B
G
YARIS (EM02C4EL)
V
M OVERALL ELECTRICAL WIRING DIAGRAM
Rr E
DEF
Rear 8 C (∗3)
Window Off
1 A Defogger SW 8 A (∗4)
1 M2(A), O1(B)
Rear Window On HO D3(A), (C), V2(B)
Defogger Spiral Cable
E 1 B
J31
Noise Filter
(Rear Window Defogger)
1 B 1 A (∗1)
R
Engine ECU
< 6–14>
1 B (∗2) 1
W–B 1 C (∗7) B2
V2(B) Horn
(∗6) 1 D (∗5) Horn SW
5
D40 W–B
Junction 9 DE1
Connector (∗5)
7
11
D88
(∗6)
(∗6)
Junction
W–B
W–B
5 Connector
(∗6)
5
B
W–B
E10
(∗5)
Junction
W–B
Connector
3 5A (LHD) 7
1 5A (RHD) 5 5A
O1 D1 D1
30 YARIS
∗ 1 : 6 Speaker
A u d io S y s te m ∗ 2 : Except 6 Speaker
∗ 3 : Shielded
1 2 3 4
(ACC) (BAT)
7. 5A 15A
ACC DOME
Volume–
2
I4 H4
14 4D 1 Speaker (Rear LH) Speaker (Rear RH) Volume+
2 1 2 1
Seek–
L
R
R
W
W
GR
MODE Seek+
D89
Stereo Jack Adapter Assembly
5 IJ1 4 IJ1 5 HJ1 4 HJ1
8 AD2
D32 AL0 AR0 ASGN AGND AUX0
V2(B)
Steering Pad SW
Y
B
R
W
W
BR
GR
Antenna Amplifier
1 2 3 5 4
9 B 8 B 10 B
D3(C), V2(B)
Spiral Cable
B 5 JD2 4 JD2 15 JD2 14 JD2 AU2 EAU AU1
1 5 C 4 C 6 C
R
R
(∗3)
(∗3)
L
B
Y
B
R
W
P
BE
LG
3 A 4 A 8 A 6 B 2 B 3 B 1 B 17 C 15 C 16 C 18 C 19 C 8 C 6 C 7 C
ACC B ANT RL– RL+ RR– RR+ AL1 AR1 ASGN AGND AUX1 SW2 SWG SW1
YARIS (EM02C4EL)
Y
V
P
W–B
GR
(∗1)
(∗1)
(∗1)
(∗1)
2 4 2 4
– + – +
Y
V
P
GR
(∗2)
(∗2)
(∗2)
(∗2)
D47
Tweeter (RH)
D48
Tweeter (LH)
1 3 1 3
Y
V
P
GR
(∗1)
(∗1)
(∗1)
(∗1)
L
V
P
GR
2 1 2 1
F6 G6
Speaker (Front Door RH) Speaker (Front Door LH)
D3
M
403
31 YARIS (Cont. next page)
404
C o m b in a tio n M e te r
1 2 3 4
(IG) (BAT) (IG)
∗ 1 : From Jan. 2008 Production until Oct. 2009 Production
∗ 2 : Before Jan. 2008 Production
10A 7. 5A 7. 5A ∗ 3 : w/ ABS
ECU–IG ECU–B MET ∗ 4 : w/o ABS
∗ 5 : From Jan. 2009 Production
∗ 6 : Before Jan. 2009 Production
2 ∗ 7 : From Oct. 2009 Production
24 4B 1
Taillight and
Illumination System
< 15–5> < 15–6>
16 AA2 (LHD) 30 4B 2 4S 1 4M
L
25 AA2 (RHD)
B
(∗4)
L
B
L
16
2 E 1 E 14 E 16 F (∗7)
2 C 1 C 14 C 16 D (∗1) D1(A), (C), (E), D2(B), (D), (F)
A37
Junction
Connector
2 A 1 A 14 A 16 B (∗2) Combination Meter
20
B
(∗4)
11 CA2
Tail
P/S
Dial
ABS
SRS
Door
5V IC
Pointer
Driver' s
Seat Belt
Temp. Hot
Temp. Cool
Electronic Key
Display
B
(∗4)
CPU
YARIS (EM02C4EL)
Tachometer
Speedometer
I/F I/F I/F I/F
M OVERALL ELECTRICAL WIRING DIAGRAM
Clock
Buzzer SW TRIP
Drive SW
Monitor
3 E 24 E 16 E 17 E (∗7)
3 C 24 C 16 C 17 C (∗1)
3 A 24 A 16 A 17 A (∗2)
11
P P P
AD3
(∗4) (∗4) (∗4)
V
SB
BR
(∗3)
W–B
(∗4) 1 4C
3
8 4C
Gage
13 4A Power Steering
ABS System
< 19–2> < 36–2>
J5
Fuel Suction Pump
and Gage Assembly
P
BR
(∗4)
(∗4)
(∗4)
19
W–B
W–B
2
1 3 2
V
G
(∗4)
IG+ SI SE BE(∗5)
D36
Junction Connector
20
A1 J1 O D3
(∗6) Engine ECU
C23 < 6–16>
Speed Sensor
31 YARIS (Cont' d)
C o m b in a tio n M e te r
5 6 7 8
Headlight System
< 9–1> < 10–1>
Rear Fog Light System
< 17–4>
Front Fog Light System
< 17–2>
14 F 15 F 8 F 6 F 7 F (∗7)
D1(A), (C), (E), D2(B), (D), (F) 14 D 15 D 8 D 6 D 7 D (∗1)
Combination Meter 14 B 15 B 8 B 6 B 7 B (∗2)
Beam
Brake
Charge
Turn LH
Turn RH
Rear Fog
Front Fog
Check Engine
Oil Pressure
LED Driver
CPU
CAN Controller
YARIS (EM02C4EL)
CAN I/F
21 E 20 E 2 F 1 F 12 F 4 F 11 F (∗7)
21 C 20 C 2 D 1 D 12 D 4 D 11 D (∗1)
21 A 20 A 2 B 1 B 12 B 4 B 11 B (∗2)
V
Y
18 AD3 19 AD3
Y
2
A10
Brake Fluid Level
W–B
Warning SW
V
Y
Y
Engine Control
System< 6–19>
1
(LHD)
(RHD)
(RHD)
Headlight System
< 9–1> < 10–1>
1
V
Charging System< 4–3>
Multiplex Communication
System (CAN)< 8–2>
C16
Engine Oil Pressure SW
V A1 Y
(RHD) (RHD)
M
405
32 YARIS
406
C o o lin g F a n O p tio n C o n n e c to r (T V S S )
1 2 3 4
(BAT) (IG) (BAT)
∗ 1 : RHD w/ ABS
30A 10A ∗ 2 : LHD, RHD w/o ABS 7. 5A
RDI ECU–IG ∗ 3 : From Jan. 2009 Production ECU–B
∗ 4 : Before Jan. 2009 Production
2 2
1 24 4B
1
L
B
A25(A), A37(B) 4 A (∗1)
Junction Connector 16 B (∗2)
5 A 6 A (∗1)
17 B 18 B (∗2)
R
A35
B
B
LG
Option Connector
5 1B 6 1B 1 1
TRIG HDCY
2 3
1 2
1 5
3 1 4
+B TRIG CTYH
8 1B 7 1B 1 1 1
YARIS (EM02C4EL)
M OVERALL ELECTRICAL WIRING DIAGRAM
GND
L
L
BE
LG
(∗3)
(∗4)
W–B
2 A36
Option Connector
2
2
17 AD5 4 AA2 B
M
A8
Cooling Fan Motor
L
A14
Radiator Fan Resistor
O
W
1
BE
LG
(∗3)
(∗4)
1
LG
W–B
W–B
A1 A1
Memo
408
A ir C o n d itio n e r (B e fo re J a n . 2 0 0 9 P ro d u c tio n )
1 2 3 4
(BAT) (IG) (IG)
40A 10A 7. 5A L
HTR GAUGE A/C
∗ 3 : From Jan. 2008 Production R
∗ 4 : Before Jan. 2008 Production
2 ∗ 5 : Before Jan. 2007 Production
∗ 6 : From Jan. 2007 Production until Jan. 2008 Production
1
10 4S 29 4B 1 1
LG
O
5 2 1 5
7 CA1
4 HTR HTR SUB1
Relay /AC MG
12 DE1 11 AA2
L
Relay
LG
3 1 2 3
1
O
MG+
1 4L 17 4E 7 4F 5 4Q 1 1 C8
A/C Compressor
15
LG
LG
E10
Junction
Connector
B
B
6 AE1
(LHD)
(RHD)
18
E6(A), (B), (C)
BR Rear Window Defogger SW
Y
LG
1 ED1 2 DE2
Volume SW
B
B
14 A 15 A (∗4) A/C Amplifier
(LHD)
(RHD)
IG+ MGC
13 DE1
2
M E4
Blower Motor
B/V SBLW GND SG–2 TE
1
E3 8 A 7 A (∗5) 26 B 21 B 24 B 23 B 22 B (∗3)
Blower Resistor 8 B 7 B (∗6) 26 A 21 A 24 A 23 A 22 A (∗4)
L
L 4 8 C 7 C (∗3)
YARIS (EM02C4EL)
W–B
2 3 1
L
L
LG
LG
BR
W–B
M OVERALL ELECTRICAL WIRING DIAGRAM
L
B
G
BR
W–B
10 6 7
14
HI M2 M1 LO E L 12 E10
1 2 4 Junction
0 E10 Connector
Junction 13
Connector
1
3 5
L
GR
2 5
W–B
W–B
(LHD)
(RHD)
R
D40
W–B
3 Junction
Connector
1 DE2 2 ED1 11
4
9 DE1
E1 1
9 5
W–B
Blower SW
W–B
E2
W–B
W–B
W–B
3 5A (LHD)
(LHD)
D2 D1 D1
33 YARIS (Cont' d)
A ir C o n d itio n e r (B e fo re J a n . 2 0 0 9 P ro d u c tio n )
5 6 7 8
∗ 1 : RHD w/ ABS
∗ 2 : LHD, RHD w/o ABS
∗ 3 : From Jan. 2008 Production
∗ 4 : Before Jan. 2008 Production
Engine ECU
< 6–12>
B
R
21 AA2 20 AA2
R
8 AD5 9 AD5
W
GR
O
16 DE1 11 DE1 3 DE1
2 DE1 3 AE1
O
W
GR
W
GR
1 B 17 B 19 B 12 B 2 B (∗3)
1 A 17 A 19 A 12 A 2 A (∗4)
CFN+ AC1 ACT PSW CFN–
W
W
W
W
YARIS (EM02C4EL)
12 A 13 A 14 A (∗1) 2 4
4 B 6 B 5 B (∗2) +S CUT+
A25(A), A37(B)
Junction Connector
A3
Pressure SW
–S CUT–
3 1
W–B
W–B
W–B
A1
M
409
34 YARIS
410
∗ 1 : w/ Security Indicator Lamp
E n g in e Im m o b ilis e r S y s te m (w /o S m a rt E n try & S ta rt S y s te m ) ∗ 2 : From Jan. 2009 Production
∗ 3 : Before Jan. 2009 Production
1 2 3 4
(BAT) (IG)
7. 5A 7. 5A
ECU–B IGN
1 21 4E
L
D24
25 AA2 Transponder Key Amplifier
L
Transponder Key Coil
Engine ECU < 6–8>
30 4B
12 4H
R
O
W
BE
(∗2)
(∗3)
VC5 CODE TXCT AGND
P
1 4 5 7
11 A 8 AD4 17 AD4
D36(A), D37(B)
Junction Connector
P
V
G
GR
2 B
W
BE
(∗2)
(∗3)
L
1 2 13 12 14 15 4 5
+B IG EFIO EFII VC5 CODE TXCT AGND
LG
(∗1)
W–B
B
O
W
BE
YARIS (EM02C4EL)
(∗2)
(∗3)
2
M OVERALL ELECTRICAL WIRING DIAGRAM
D25
Security
Indicator Lamp
DLC3< 7–2>
6
(∗1)
W–B
Unlock Warning SW
< 18–4>
Door Courtesy SW
(Front LH) (LHD)< 14–3>
Door Courtesy SW
(Front RH) (RHD)< 14–3>
W–B 5 D40
Junction
Connector
11
W–B
(RHD)
W–B
(LHD)
3 5A 1 5A
D1
Memo
412
A ir C o n d itio n e r (F ro m J a n . 2 0 0 9 P ro d u c tio n )
1 2 3 4
(BAT) (IG) (IG)
40A 10A 7. 5A L
HTR GAUGE A/C
R
2
1
10 4S 29 4B 1 1
LG
BE
5 2 1 5
7 CA1
4 HTR HTR SUB1
Relay /AC MG
11 AA2
L
Relay
LG
3 1 2 3
1
L
MG+
1 4L 17 4E 7 4F 5 4Q 1 1 C8
A/C Compressor
15
LG
LG
D88
Junction
Connector
18 6 AD6
D98
BR Rear Window Defogger SW
B
Y
LG
Volume SW
D99
14 15 A/C Amplifier
IG+ MGC
M D96
Blower Motor
B/V SBLW GND SG–2 TE
1
D95 8 7 26 21 24 23 22
Blower Resistor
L
L 4
YARIS (EM02C4EL)
W–B
2 3 1
L
L
LG
LG
BR
W–B
M OVERALL ELECTRICAL WIRING DIAGRAM
L
B
G
BR
W–B
10 6 7
14
HI M2 M1 LO E L 12 D88
1 2 4 Junction
0 D88 Connector
Junction 13
Connector
1
3 5
L
GR
3
R
W–B
W–B
W–B
D93 1
9 5
Blower SW W–B
R D94
A/C Thermistor No. 1
5 5A
2
D2 D1 D2 D1
35 YARIS
A ir C o n d itio n e r (F ro m J a n . 2 0 0 9 P ro d u c tio n )
5 6 7 8
∗ 1 : RHD w/ ABS
∗ 2 : LHD, RHD w/o ABS
Engine ECU
< 6–12>
B
R
GR
21 AA2 20 AA2
R
8 AD5 9 AD5 3 AD6
GR
BE
W
GR
1 17 19 12 2
CFN+ AC1 ACT PSW CFN–
W
W
W
W
YARIS (EM02C4EL)
12 A 13 A 14 A (∗1) 2 4
4 B 6 B 5 B (∗2) +S CUT+
A25(A), A37(B)
Junction Connector
A3
Pressure SW
–S CUT–
3 1
W–B
W–B
W–B
A1
M
413
36 YARIS
414
A B S (F ro m O c t. 2 0 0 9 P ro d u c tio n )
1 2 3 4
(IG) (IG) (BAT) (BAT)
2 2
1 4M 24 4B 1 1
B
4 A (RHD)
16 B (LHD)
B
A25(A), A37(B) A11 A7
Junction Connector Speed Sensor Speed Sensor
7 A (RHD) (Front LH) (Front RH)
19 B (LHD) 2 1 2 1
1 E
B
P
V
B
R
G
W
ABS
Brake
Display LED Driver
34 19 18 7 6 12 24
IG1 FL+ FL– FR+ FR– +BS +BM
CPU A38
Skid Control ECU with Actuator
CAN Controller
SP1 STP CANL CANH RL– RL+ RR– RR+ GND1 GND2
22 28 14 25 4 5 16 17 1 13
YARIS (EM02C4EL)
CAN I/F I/F
M OVERALL ELECTRICAL WIRING DIAGRAM
D1(E)
Combination Meter
L
P
B
Y
G
LG
W–B
W–B
24 E 21 E 20 E 17 E
11 AD3
11 AJ1 10 AJ1 9 AJ1 8 AJ1
L
P
B
Y
LG
BR
Stop Lamp SW
< 16–3>
BR
BR
Multiplex
Communication
System (CAN)< 8–2>
W–B
1 2 1 2
a1 Z1
Speed Sensor Speed Sensor
(Rear LH) (Rear RH)
D3 A2