Professional Documents
Culture Documents
Avanza Ewd
Avanza Ewd
NOTICE
Always follow the directions given in the above repair manuals when handling
supplemental restraint system components (such as removal, installation,
inspection, etc.) in order to prevent accidents and supplemental restraint
system malfunction.
©2011
All rights reserved. This book may not be
reproduced or copied, in whole or in part, without
the written permission of Toyota Motor
Corporation.
AVANZA
ELECTRICAL WIRING DIAGRAM
Section Code Page
INTRODUCTION . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . A . . . . 2
TROUBLESHOOTING . . . . . . . . . . . . . . . . . . . . . . . . . C . . . . 12
ABBREVIATIONS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . D . . . . 17
RELAY LOCATIONS . . . . . . . . . . . . . . . . . . . . . . . . . . . F . . . . 20
SYSTEM CIRCUITS . . . . . . . . . . . . . . . . . . . . . . . . . . . . H . . . . 45
AVANZA (EM19Y0E)
A INTRODUCTION
This manual consists of the following 13 sections:
TROUBLE–
C Describes the basic inspection procedures for electrical circuits.
SHOOTING
GLOSSARY OF
E TERMS AND Defines the symbols and functions of major parts.
SYMBOLS
Shows position of the Electronic Control Unit, Relays, Relay Block, etc.
F RELAY LOCATIONS
This section is closely related to the system circuit.
ELECTRICAL Describes position of Parts Connectors, Splice points, Ground points, etc.
G
WIRING ROUTING This section is closely related to the system circuit.
H Electrical circuits of each system are shown from the power supply through ground
points. Wiring connections and their positions are shown and classified by code
SYSTEM CIRCUITS according to the connection method. (Refer to the section, ”How to use this manual”).
* Only wiring information for complete circuits is included.
I GROUND POINT Shows ground positions of all parts described in this manual.
POWER SOURCE
J Describes power distribution from the power supply to various electrical loads.
(Current Flow Chart)
Describes the form of the connectors for the parts appeared in this book.
K CONNECTOR LIST
This section is closely related to the system circuit.
PART NUMBER OF
L Indicates the part number of the connectors used in this manual.
CONNECTORS
OVERALL
Provides circuit diagrams showing the circuit connections.
M ELECTRICAL
* Only wiring information for complete circuits is included.
WIRING DIAGRAM
AVANZA (EM19Y0E)
HOW TO USE THIS MANUAL B
The actual wiring of each system circuit is shown from the point where the power
source is received from the battery as far as each ground point. (All circuit
diagrams are shown with the switches in the OFF position.)
When troubleshooting any problem, first understand the operation of the circuit
where the problem was detected (see System Circuit section), the power source
supplying power to that circuit (see Power Source section), and the ground points
(see Ground Point section).
Example:
*The information in this manual is Front right door When inspecting or repairing,
refer to the Repair Manual.
about the wire harnesses.
Information about component and
assembly parts is for reference,
but in some cases this reference
information might not be included or
might differ from the actual vehicle.
When inspecting or repairing a vehicle,
refer to the relevant Repair Manual.
Wire harness
Component parts
Assembly parts
AVANZA (EM19Y0E)
B HOW TO USE THIS MANUAL
* The system shown here is an EXAMPLE ONLY. It is different to the actual
circuit shown in the SYSTEM CIRCUITS SECTION.
[A]
Stop Light
[M]
(BAT) (IG)
15A 7.5A
STOP GAUGE
[B] 1 3 IB 4 IB
R–L
W–R
(S/D)
7 3C
L
2
[C] [G]
H6
Stop Light Switch
Assembly 14 CH1 15 3C
R–L
(W/G)
(S/D)
R
L
G–W
Combination Meter
4
Skid Control ECU
15 CH1 [E]
Lights
Rear
G–W
Assembly
[D]
H7
(S/D)
13
L
G–W
Y–G
[F] [O]
H4
7 8 Light Failure Sensor 4
2 1 11
G–R
[I]
1
G–R
HJ1 [N]
[H]
W–B
G–B
G–R
G–R
(Shielded)
Rear Combination Light
4 3
Assembly RH
Assembly LH
2
H17
[J]
Stop
Stop
Center Stop
Light Assembly
H9
1
J7
3 6
W–B
W–B
W–B
1
W–B
HJ1
W–B
H1 [K] H2
50 [L]
AVANZA (EM19Y0E)
B
[A] : System Title [I] : Indicates the wiring color.
[B] : Indicates a Relay Block. No shading is used and Wire colors are indicated by an alphabetical code.
only the Relay Block No. is shown to distinguish it Copper wires
from the J/B
B = Black W = White BR = Brown
Example: Indicates Relay Block No.1
L = Blue V = Violet SB = Sky Blue
[C] : ( ) is used to indicate different wiring and R = Red G = Green LG = Light Green
connector, etc. when the vehicle model, engine
type, or specification is different. P = Pink Y = Yellow GR = Gray
[D] : Indicates related system. O = Orange BE = Beige DG = Dark Gray
[E] : Indicates the code for the (male and female) Aluminum wires
connectors which are used to join two wire LA = Lavender
harnesses. The connector code consists of two NOTICE:Do not splice into aluminum wires for power
alphabetical and one numerical characters. sources or signals.
The first letter indicates the basic wire color and the
second letter indicates the color of the stripe.
Example: L–Y
Female Male ( )
AVANZA (EM19Y0E)
B HOW TO USE THIS MANUAL
[N] : Indicates a wiring Splice Point.
Example:
AVANZA (EM19Y0E)
B
[P] : Parts Location
Code See Page Code See Page Code See Page
H4 36 H7 36 H17 38
H6 36 H9 38 J7 38
Code See Page Junction Block and Wire Harness (Connector Location)
3C 22 Instrument Panel Wire and J/B No.3 (Instrument Panel Brace LH)
IB 20 Instrument Panel Wire and Instrument Panel J/B (Lower Finish Panel)
[P] : Indicates reference pages showing the parts locations in the system circuit on the vehicle.
Example : Code ”H4” (Light Failure Sensor) is on page 36 of the manual.
* The first character of the code indicates the alphabetical code allocated to the wire harness, and the
second character indicates the serial number of the parts connected to the wire harness.
Example : H 4
Serial number for the connected parts
Code for the wire harness
[Q] : Indicates the reference page showing the position on the vehicle of Relay Block Connectors in the system circuit.
Example : Connector ”1” is described on page 18 of this manual and is installed on the left side of the instrument
panel.
[R] : Indicates the reference page showing the position on the vehicle of J/B and Wire Harness in the system circuit.
Example : Connector ”3C” connects the Instrument Panel Wire and J/B No.3. It is described on page 22 of this
manual, and is installed on the instrument panel left side.
[S] : Indicates the reference page describing the wiring harness and wiring harness connector (the female wiring
harness is shown first, followed by the male wiring harness).
Example : Connector ”CH1” connects the Engine Room Main Wire (female) and Instrument Panel Wire (male).
It is described on page 42 of this manual, and is installed on the left side kick panel.
[T] : Indicates the reference page showing the position of the ground points on the vehicle.
Example : Ground point ”H2” is described on page 50 of this manual and is installed on the back panel center.
AVANZA (EM19Y0E)
B HOW TO USE THIS MANUAL
The ground points circuit diagram shows the connections from all major parts to the respective ground points. When
troubleshooting a faulty ground point, checking the system circuits which use a common ground may help you identify
the problem ground quickly. The relationship between ground points ( A1 , A2 and D4 shown below) can also be
checked this way.
I GROUND POINT
D43
Junction
H23 Connector
12 9
DLC3 BR BR BR 10 6 (Shielded)
(SG) HB4 DB1
D63
5 BR Throttle Body
(Shielded)
(Shielded)
(L) Assembly
D60
A20 4 3 BR Injector Driver
W–B 8 (E1) (Bank 1)
Headlight LH
(LH E)
L5 2 11 BR
W–B 3 W–B 7 (E1)
Maltiplex Network
Master Switch Assembly(E) LA1
1 D2
BR ECM
(E01)
Connector
A22
BR
W–B 4 Junction
Cooling Fan
(E)
A25
Motor No.2 BR
(E02)
3
W–B
D4 (5L–E)
A8
Headlight RH W–B
(RH E)
A5 C2
W–B
A23 5 C4
Side Turn Signal Light W–B W–B W–B W–B Fog Light
Assembly LH (E) CA1 (E) Assembly RH
A11 A10
W–B
I9 12 7 A1
Outer Mirror W–B W–B W–B W–B Side Turn Signal
Switch Assembly (E) IH2 HA1 (E) Light Assembly LH
W–B
A6
Headlight Assembly RH W–B K5
(E) 3
W–B W–B Clock Assembly
KA1 (E)
W–B
A21
Headlight Assembly LH W–B W–B
(E)
20 W – B (Shielded)
A1
19 W – B (Shielded)
W–B
(GND2) 18 W – B (Shielded)
A24
Brake Booster
Connector
(GND1)
W–B
17 W – B (Shielded)
B36
21 16
W–B W–B
W–B
(GND) AB1
B19
Skid Control ECU
Assembly 12 6
W–B W–B W–B
(GND) AB1 AB1
W–B
W–B
W–B
A2
* The system shown here is an EXAMPLE ONLY. It is different to the actual circuit shown in the SYSTEM CIRCUITS SECTION.
AVANZA (EM19Y0E)
B
The ”Current Flow Chart” section, describes which parts each power source (fuses, fusible links, and circuit breakers)
transmits current to. In the Power Source circuit diagram, the conditions when battery power is supplied to each system
are explained. Since all System Circuit diagrams start from the power source, the power source system must be fully
understood.
10A ECU–B
Short Pin 2 2
7.5A DOME
15A EFI
Power Source
1.25B
B 1 FL MAIN
W
BA1
Battery
50A MAIN 7.5A DOME
B W 7 W W 1 2 R
1 2
2 2 AH1 1 1
7.5A AM1
B W–R 6
1 2
2 2 AH1
W
W–R
15A HAZ–RADIO
1 2 W
2
8 4
AM1
AM2
H8
Ignition or Starter
Switch Assembly
ACC
ST1
ST2
IG1
IG2
2
20A DEFOG
B–Y 1 2 W–R
1 1
* The system shown here is an EXAMPLE ONLY. It is different to the actual circuit shown in the SYSTEM CIRCUITS SECTION.
AVANZA (EM19Y0E)
B HOW TO USE THIS MANUAL
K CONNECTOR LIST
A1 [A] A2 A3 [C]
Black Gray
1 2 3 4 1 2 3 4 5 6 7
1 2 3 4
5 6 7 8
[B] [D]
B1 B2
Black Gray
1 2
3 4 5 6
1 2 3 4 5
6 7 8 9 10111213
K CONNECTOR LIST
BA1 Black
[E] BD2 Gray [F]
1 2 3 4 4 3 2 1
1 2 3 4 5 5 4 3 2 1 5 6 7 8 9 10 11 11 10 9 8 7 6 5
6 7 8 9 10 11 12 13 13 12 11 10 9 8 7 6
[A] : Indicates connector to be connected to a part. (The numeral indicates the pin No.)
Short Terminal
[E] : Indicates the connector shapes which are used to join wire harnesses.
On Left : Female connector shapes
On Right : Male connector shapes
Numbers indicate pin numbers.
[F] : Indicates connector colors. (Connectors with not indicated colors are white)
10
AVANZA (EM19Y0E)
B
A1 Side Turn Signal Light Assembly LH 90980–11019 B22 Headlight Assembly LH 90980–12470
A2 Side Turn Signal Light Assembly LH 90980–11163 B23 Headlight Assembly LH 90980–12253
A3 Head Cleaner Motor and Pump Assembly 90980–12292 B24 Headlight Assembly LH 90980–10463
A5 Front Wiper Deicer (Windshield Glass) 90980–10943 B26 Ambient Temperature Sensor 90980–12470
A9 Cooling Fan ECU 90980–11252 B30 Millimeter Wave Radar Sensor Assembly 90980–11003
A10 Front Speed Sensor LH 90980–11207 B32 Low Pitched Horn Assembly 90980–10789
A11 Windshield Wiper Motor Assembly 90980–11599 B33 Headlight Assembly RH 90980–10121
Not all of the above part numbers of the connector are established for the supply.
11
AVANZA (EM19Y0E)
C TROUBLESHOOTING
To Ignition SW VOLTAGE CHECK
IG Terminal
(a) Establish conditions in which voltage is present at the check
point.
Example:
Fuse [A] – Ignition SW on
[B] – Ignition SW and SW 1 on
[A] [C] – Ignition SW, SW 1 and Relay on (SW 2 off)
(b) Using a voltmeter, connect the negative lead to a good ground
SW 1 Voltmeter point or negative battery terminal, and the positive lead to the
connector or component terminal.
[B] This check can be done with a test light instead of a voltmeter.
Relay
[C]
SW 2 Solenoid
SW
If the circuit has diodes, reverse the two leads and check
again.
When contacting the negative lead to the diode positive side
Ohmmeter and the positive lead to the negative side, there should be
continuity.
When contacting the two leads in reverse, there should be no
continuity.
Diode
Digital Type Analog Type (c) Use a volt/ohmmeter with high impedance (10k /V
minimum) for troubleshooting of the electrical circuit.
12
AVANZA (EM19Y0E)
C
To Ignition SW FINDING A SHORT CIRCUIT
IG Terminal
(a) Remove the blown fuse and disconnect all loads of the fuse.
(b) Connect a test light in place of the fuse.
(c) Establish conditions in which the test light comes on.
Test Light Fuse Case Example:
[A] – Ignition SW on
Short [A]
[B] – Ignition SW and SW 1 on
[C] – Ignition SW, SW 1 and Relay on (Connect the
Relay) and SW 2 off (or Disconnect SW 2)
SW 1 (d) Disconnect and reconnect the connectors while watching the
test light.
Short [B] The short lies between the connector where the test light
stays lit and the connector where the light goes out.
Disconnect
Disconnect (e) Find the exact location of the short by lightly shaking the
problem wire along the body.
Light Relay
CAUTION:
(a) Do not open the cover or the case of the ECU unless
Short [C] absolutely necessary. (If the IC terminals are touched,
the IC may be destroyed by static electricity.)
(b) When replacing the internal mechanism (ECU part) of
Disconnect
the digital meter, be careful that no part of your body or
clothing comes in contact with the terminals of leads
SW 2 Solenoid from the IC, etc. of the replacement part (spare part).
Pull Up Pull Up
13
AVANZA (EM19Y0E)
C TROUBLESHOOTING
Reference: HOW TO REPLACE TERMINAL
(with terminal retainer or secondary locking device)
10 1. PREPARE THE SPECIAL TOOL
3 1
HINT:To remove the terminal from the connector, please
construct and use the special tool or like object shown on
the left.
2. DISCONNECT CONNECTOR
0.2
1 (mm)
”Case 1”
[Retainer at Full Lock Position] Raise the terminal retainer up to the temporary lock
position.
Terminal
Stopper Retainer
14
AVANZA (EM19Y0E)
C
Tool
Tab
Tab
”Case 1”
Type where terminal retainer is pulled
up to the temporary lock position (Pull
Type).
Retainer
at Temporary Lock Position
[Male] [Female]
Tool Tool
Press Down
[Male] Press Down [Female]
15
AVANZA (EM19Y0E)
C TROUBLESHOOTING
Push the terminal retainer down to the temporary lock position.
Retainer at
Full Lock Position
Retainer at
Temporary Lock Position
[Male] [Female]
Locking Lug (c) Release the locking lug from terminal and pull the terminal out
from rear.
Tool
16
AVANZA (EM19Y0E)
ABBREVIATIONS D
ABBREVIATIONS
The following abbreviations are used in this manual.
* The titles given inside the components are the names of the terminals (terminal codes) and are not treated as being
abbreviations.
17
AVANZA (EM19Y0E)
E GLOSSARY OF TERMS AND SYMBOLS
BATTERY GROUND
Stores chemical energy and The point at which wiring attaches to
converts it into electrical energy. the Body, thereby providing a return
Provides DC current for the auto’s path for an electrical circuit; without a
various electrical circuits. ground, current cannot flow.
CIGARETTE LIGHTER
An electric resistance heating 2. DOUBLE
FILAMENT
element.
18
AVANZA (EM19Y0E)
E
RELAY SPEAKER
Basically, an electrically operated An electromechanical device which
1. NORMALLY switch which may be normally creates sound waves from current
CLOSED closed (1) or open (2). flow.
Current flow through a small coil
creates a magnetic field which either
opens or closes an attached switch.
2. NORMALLY SWITCH, MANUAL
OPEN Opens and closes
circuits, thereby
1. NORMALLY
OPEN stopping (1) or
allowing (2) current
flow.
RELAY, DOUBLE THROW
A relay which passes current 2. NORMALLY
through one set of contacts or the CLOSED
other.
SHORT PIN
WIRES
Used to provide an unbroken
Wires are always drawn as
connection within a junction block. (1) NOT straight lines on wiring
CONNECTED diagrams.
Crossed wires (1) without a
black dot at the junction are
SOLENOID not joined;
An electromagnetic coil which forms crossed wires (2) with a
a magnetic field when current flows, (2) SPLICED black dot or octagonal ( )
to move a plunger, etc. mark at the junction are
spliced (joined)
connections.
19
AVANZA (EM19Y0E)
F RELAY LOCATIONS
[Engine Compartment]
20
AVANZA (EM19Y0E)
F
[Instrument Panel]
(LHD)
Door Control Door Control Transmission Control
Relay Receiver ECU Assembly * 1:Refer to the Service Bulletin
for the installation position of the parts.
ECM
Transponder Key
Fuse Block Assembly ECU Assembly
*1
(RHD)
Door Control Door Control
* 1:Refer to the Service Bulletin Receiver Relay
for the installation position of the parts.
ECM
Turn Signal Flasher
Assembly
Transmission Control
ECU Assembly
*1
21
AVANZA (EM19Y0E)
F RELAY LOCATIONS
1 : Engine Room R/B Assembly
Engine Compartment Right (See Page 20)
: Engine Room J/B Assembly
HORN Relay
(MGC) Relay
H-LP RH
H-LP LH
1 10A 2
1 10A 2
1
HEAD Relay 5 3
RAD Relay
2
2 20A 1
(FR FOG)
1 30A 2 1
(ABS NO.2) 2 1 1B
1 15A 2 5
EFI
2 10A 1 1 10A 2 3
(ECU-B) (A/C NO.1)
2 10A 1 1 10A 2 (from Engine No. 2 Wire)
STOP TAIL
1 10A 2 2 1 2 1
HORN 5 5
2 10A 1 3 3
BACK UP
Black
1 1 1A 1
50A AM1 2 1 1
(for High Current) 40A IG1
(for High Current)
40A (ABS NO.1) 2 1 1 2
(for High Current)
30A RAD 2 1 1 2
(for High Current) 1C
1
30A AM2
(for High Current)
40A HTR
(for High Current)
22
AVANZA (EM19Y0E)
2
IG Relay
1
5
3
1
2
5
4
3
FOG Relay
2
1
5
3
2
: Fuse Block Assembly
ST Relay
2 7.5A 1
(HTR SUB)
1
1 7.5A 2 2 7.5A 1
5
3
ST IG1/BACK
2
17.5A 2 2 7.5A 1
F/P Relay
1
(FR FOG LH) (DEF)
5
3
2 15A 1
2
(D/L)
110A 2 2 10A 1
E/G HAZARD
EFI MAIN Relay
110A 2
5
3
ECU IG2
1 4 2
110A 2 2 15A 1
(A/C NO.2) (CIG)
HTR Relay
120A 2 2 10A 1
FR WIP ACC
115A 2
2 1
AVANZA (EM19Y0E)
(RR WIP)
Lower Finish Panel (See Page 21)
30A POWER
(for High Current)
F
23
G ELECTRICAL WIRING ROUTING
Position of Parts in Engine Compartment
[LHD]
A9 A8 A10 A11 B14 B13
B12
B7
B6
B10
A2
B1
A3
B4
A4
A5
A1 A6 B15 B9 B5 B11 B3 B2
24
AVANZA (EM19Y0E)
G
Position of Parts in Engine Compartment
[LHD]
C11 C6 C7 C8 C15 C9 C4 C3 C2
C12
C19
C20 C22
C14 C1
D1 C27
D3
25
AVANZA (EM19Y0E)
G ELECTRICAL WIRING ROUTING
Position of Parts in Instrument Panel
[LHD]
(*4) (*2)
E39 E34 E24 E33 E31 E32 E30 E5 E6 E4
* 2:w/ SRS w/ Steering Pad Switch
* 4:w/o SRS
E37
E2 E1
E35 E3
E29 E8
E7 E10
E27 E16
E36 E9
E26
E25
E12
E28 E20 E21 E11 E22 E14 E15 E23 E18 E19 E13 E17
26
AVANZA (EM19Y0E)
G
Position of Parts in Instrument Panel
[LHD]
(*2) (*3)
E62 z3 z4 E41 E40 E43 E64 E53 E48 E61 E45 E44
*1 E58
(*3) C24
E54
(*2) C23
E63
C25
E42
E47
E46
E65
27
AVANZA (EM19Y0E)
G ELECTRICAL WIRING ROUTING
Position of Parts in Body
[LHD]
F1 F2 F3 F6 F7 H2 H3
G2
G3 H4
G6 H1
G7
G1
I2 I1 I3 I4
28
AVANZA (EM19Y0E)
G
Position of Parts in Body
[LHD]
K4 K1 J1 K2 K3 O1 M1
J3
N1
J4
J2
J10 L1
J6 L2
J5 L3
L4
J8 J7 J9 P1
29
AVANZA (EM19Y0E)
G ELECTRICAL WIRING ROUTING
Position of Parts in Engine Compartment
[RHD]
A9 A8 A7 A11 B14 B8
B12
B7
B6
B10
A2
B1
A3
B4
A4
A5
A1 A6 B15 B9 B5 B11 B3 B2
30
AVANZA (EM19Y0E)
G
Position of Parts in Engine Compartment
[RHD]
C11 C6 C7 C8 C15 C9 C4 C3 C2
* 1:Thailand
* 2:Except Thailand
C12
(*2)
C19 C22
(*1)
C20 C26
C14 C1
D1 C27
D3
31
AVANZA (EM19Y0E)
G ELECTRICAL WIRING ROUTING
Position of Parts in Instrument Panel
[RHD]
(*4) (*2)
E5 E6 E4 E10 E30 E31 E32 E24 E34 E39
* 2:w/ SRS w/ Steering Pad Switch
* 4:w/o SRS
E2 E37
E3 E35
E8 E33
E1 E7
E16 E36
E17 E25
E14 E12
E13
E15 E18 E19 E9 E22 E21 E20 E23 E11 E26 E27 E29 E28
32
AVANZA (EM19Y0E)
G
Position of Parts in Instrument Panel
[RHD]
E61 E45 E53 E48 E41 E40 z5 E43 E62
* 1:Refer to the Service Bulletin
for the installation position of the parts.
* 2:w/ SRS w/ Steering Pad Switch
* 3:w/ SRS w/o Steering Pad Switch
E58
E64
*1 (*2)
z3
C24
(*3)
z4
C23
(*3)
E54
E44
(*2)
E63
C25
E42
E46
E65
E59
33
AVANZA (EM19Y0E)
G ELECTRICAL WIRING ROUTING
Position of Parts in Body
[RHD]
F1 F2 F3 F4 F5 H2 H3
G2
G3 H4
G4 H1
G5
G1
I2 I1 I3 I4
34
AVANZA (EM19Y0E)
G
Position of Parts in Body
[RHD]
(*2) (*1)
K4 K1 J15 J1 K2 K3 K5 J13 O1 M1
* 1:Malaysia
* 2:Except Malaysia
J3
N1
J4
J6 J2
J5 L1
J14 L2
J8 L3
J7 J11 J9 J12 P1 Q1 L4 Q2
35
AVANZA (EM19Y0E)
G ELECTRICAL WIRING ROUTING
: Location of Ground Points
[LHD]
Engine Wire C2 C1
36
AVANZA (EM19Y0E)
G
: Location of Connector Joining Wire Harness and Wire Harness
[LHD]
BE3 BE5 BE6 EE1 EE2 AE1 KE1 AE3 AE2
AE4
CE1
FE2
GE2
AE5
GJ1
JE2
JE1
BE4 BE7
Front Door
RH Wire
Engine Room
No. 2 Wire Engine Room
Main Wire
B1
Front Door
LH Wire
E3
Floor Wire Instrument Panel Wire Engine Wire
37
AVANZA (EM19Y0E)
G ELECTRICAL WIRING ROUTING
: Location of Connector Joining Wire Harness and Wire Harness
: Location of Ground Points
[LHD]
Back Door
No. 2 Wire
MJ1
Front Door J1
LH Wire
Floor Wire
38
AVANZA (EM19Y0E)
Memo
39
AVANZA (EM19Y0E)
G ELECTRICAL WIRING ROUTING
: Location of Ground Points
[RHD]
Engine Wire C2 C1
40
AVANZA (EM19Y0E)
G
: Location of Connector Joining Wire Harness and Wire Harness
[RHD]
CE1 BE2 BE3 EE2 EE1 AE3 AE1 KE1 AE2
FE1
GE1
JE2
BE4
JE1
BE1
BE7
Roof Wire
E5
Front Door
LH Wire E4
Engine Room
Engine Room Main Wire
No. 2 Wire
A2
A1
41
AVANZA (EM19Y0E)
G ELECTRICAL WIRING ROUTING
: Location of Connector Joining Wire Harness and Wire Harness
: Location of Ground Points
[RHD]
Back Door
No. 2 Wire
MJ1
Front Door J1
LH Wire
Floor Wire
42
AVANZA (EM19Y0E)
G
[Antenna]
43
AVANZA (EM19Y0E)
Memo
44
AVANZA (EM19Y0E)
SYSTEM CIRCUITS H
AVANZA
ELECTRICAL WIRING DIAGRAM
SYSTEM CIRCUITS
Page
ABS ...................................................................................................................... 100
Air Conditioner ................................................................................................... 184
Audio System ..................................................................................................... 168
Back-Up Light ..................................................................................................... 86
Charging .............................................................................................................. 56
Cigarette Lighter ................................................................................................. 164
Combination Meter ............................................................................................. 172
Cooling Fan ......................................................................................................... 182
DLC3 .................................................................................................................... 74
Door Lock Control (LHD) ................................................................................... 124
Door Lock Control (RHD) .................................................................................. 128
ECT and A/T Indicator ........................................................................................ 60
Engine Control .................................................................................................... 60
Engine Immobiliser System .............................................................................. 72
EPS ...................................................................................................................... 108
Front Fog Light ................................................................................................... 80
Front Wiper and Washer .................................................................................... 158
Headlight ............................................................................................................. 76
Horn ..................................................................................................................... 162
Ignition ................................................................................................................ 58
Illumination ......................................................................................................... 90
Interior Light ....................................................................................................... 96
Key Reminder ..................................................................................................... 120
Light Reminder ................................................................................................... 120
Multiplex Communication System (CAN) ........................................................ 50
Power Outlet ....................................................................................................... 164
Power Source ..................................................................................................... 46
Power Window (LHD) ......................................................................................... 150
Power Window (RHD) ........................................................................................ 154
Rear Window Defogger ...................................................................................... 166
Rear Wiper and Washer ..................................................................................... 160
Remote Control Mirror ....................................................................................... 114
Seat Belt Warning ............................................................................................... 118
Shift Lock ............................................................................................................ 116
SRS ...................................................................................................................... 103
Starting ................................................................................................................ 52
Stop Light ............................................................................................................ 88
Taillight ................................................................................................................ 90
Theft Deterrent .................................................................................................... 144
Turn Signal and Hazard Warning Light ............................................................ 82
Wireless Door Lock Control (LHD) ................................................................... 132
Wireless Door Lock Control (RHD) ................................................................... 138
45
AVANZA (EM19Y0E)
Power Source
50A AM1
2
1 2 W W
1 AE1
30A AM2
6
1 2 B B
1 AE2
10A H–LP LH
HEAD Relay
5 3 1 2
1 2
10A H–LP RH
1 2
HTR Relay
2 1
40A HTR
5
1 2 G G 5 3 L
1 AE2 2 2
4
30A RAD
1 2 2
W–B
10A (A/C NO. 1)
1 2
W–B
40A IG1
1 1
1 2 R R
1B 1 AE1
50A EPS
10A STOP 1 2
B
1 2
30A (ABS NO. 2)
FL MAIN 1 2
2. 0L 10A BACK UP
1 2
10A (ECU–B)
10A TAIL 1 2
1 2
10A HORN
Battery
15A EFI 1 2
1 2 2 1
20A (FR FOG)
5
1 2 W–R W–R 3 5 V
1 AE4 2 2
FOG Relay
46
AVANZA (EM19Y0E)
15A (CIG)
ACC 3 W–R 1 2
2
W 1 AM IG1 2 G
10A ACC
1 2
B 5 AM2 IG2 6 P
7. 5A ECU IG1
ST 4 L–B
G 1 2
2
E28
Ignition or Starter 7. 5A IG1/BACK
Switch Assembly
1 2 B–W
2
20A (DEF)
1 2
7. 5A (HTR SUB)
10A ECU IG2
L 1 2
2 P 1 2
2
10A HAZARD
10A E/G
1 2
1 2
15A (D/L)
Junction Connector
7. 5A ST
R 1 2
2 L–B 1 2
2 4
W–B
E42
20A FR WIP
2
1 2
W–B
2
15A (RR WIP)
4
R 5 3 B B 1 2
2 2 2
R–W
R–W 2 1 W–B 10A (A/C NO. 2)
2 2
IG Relay 1 2
W–B
30A POWER
B 1 2
2
1 2
V 1 2
2
4
E39
Junction Connector
E4
47
AVANZA (EM19Y0E)
Power Source
: Parts Location
Code See Page Code See Page Code See Page
26 (LHD) 26 (LHD) 27 (LHD)
E28 E39 E42
32 (RHD) 32 (RHD) 33 (RHD)
: Relay Blocks
Code See Page Relay Blocks (Relay Block Location)
1 22 Engine Room R/B Assembly (Engine Compartment Right)
2 23 Fuse Block Assembly (Lower Finish Panel)
: Ground Points
Code See Page Ground Points Location
37 (LHD)
E4 Instrument Panel Reinforcement
41 (RHD)
48
AVANZA (EM19Y0E)
Memo
49
AVANZA (EM19Y0E)
Multiplex Communication System (CAN)
E3(C)
ECM
(A/T ∗2)
(A/T ∗2)
(M/T ∗2)
(A/T ∗1)
(A/T ∗1)
G
R
G
R
E45
6 14 8 10 Junction Connector
CANH CANL
9 11 1 3
E12
DLC3
(M/T ∗2)
(A/T ∗2)
(A/T ∗2)
(A/T ∗2)
(A/T ∗2)
LG
G
P
7 A 17 A
CANH CANL
E9(A)
Transmission Control
ECU Assembly
28 29
CANH CANL
E34
Combination
Meter Assembly
50
AVANZA (EM19Y0E)
: Parts Location
Code See Page Code See Page Code See Page
26 (LHD) 26 (LHD) 27 (LHD)
E3 C E12 E45
32 (RHD) 32 (RHD) 33 (RHD)
26 (LHD) 26 (LHD)
E9 A E34
32 (RHD) 32 (RHD)
51
AVANZA (EM19Y0E)
Starting
B
(A/T) (A/T)
B
B 5 AM2 IG2
(A/T)
ST 4 L–B
E28
Ignition or Starter
Switch Assembly
(M/T)
(A/T)
B
(M/T)
(A/T)
(A/T)
L–B
L–B
L–B
1
7. 5A
ST
6 AE2 2 AE2
2
2
L–B
B
L–B
(A/T)
1 1
(M/T)
(A/T)
L–W
L–W
2
1 1C
30A
AM2
25 C
STA
1
L–B
1 1B E3(C)
ECM
B
1 B
FL MAIN L–W
2. 0L (A/T)
Battery
52
AVANZA (EM19Y0E)
B
(A/T)
E23
Park/Neutral Position
Switch Assembly
P N E
N
(A/T)
(A/T)
L–W
4 5 6
B
(A/T)
(A/T)
(A/T)
BR
R
V
2 2
3 2
ST
Relay Connector 13 5 10
Junction
E46
5 1
14 6 3
2 2
L–B
(A/T)
(A/T)
(A/T)
(A/T)
W–B
(A/T)
B–Y
LG
B
16 A 15 B 24 B
STR P N
E9(A), E10(B)
Transmission Control
ECU Assembly
L–W
(A/T)
11
Connector
Junction
E39
E4
53
AVANZA (EM19Y0E)
Starting
: Parts Location
Code See Page Code See Page Code See Page
25 (LHD) 26 (LHD) 26 (LHD)
D1 A E9 A E28
31 (RHD) 32 (RHD) 32 (RHD)
25 (LHD) 26 (LHD) 26 (LHD)
D3 B E10 B E39
31 (RHD) 32 (RHD) 32 (RHD)
26 (LHD) 26 (LHD) 27 (LHD)
E3 C E23 E46
32 (RHD) 32 (RHD) 33 (RHD)
: Relay Blocks
Code See Page Relay Blocks (Relay Block Location)
1 22 Engine Room R/B Assembly (Engine Compartment Right)
2 23 Fuse Block Assembly (Lower Finish Panel)
: Ground Points
Code See Page Ground Points Location
37 (LHD)
E4 Instrument Panel Reinforcement
41 (RHD)
54
AVANZA (EM19Y0E)
Memo
55
AVANZA (EM19Y0E)
Charging
(IG)
10A
ECU IG2
(A/T)
LG
2
Connector
Junction
(M/T)
LG
E43
9
(A/T)
R–L
2
Connector
Junction
R–L 9
E48
(M/T)
39
IG
Charge
Meter Assembly
Combination
B
C23(A)
ECM
CHG ALT
E34
36 34 A
1 1B
R–W
1 1A
4 CE1
R–W
B–W
B
1 B 4 A 2 A
B L IG
B
FL MAIN
2. 0L
IC Regulator
Battery
C16(A), D2(B)
Generator Assembly
56
AVANZA (EM19Y0E)
: Parts Location
Code See Page Code See Page Code See Page
25 (LHD) 25 (LHD) 27 (LHD)
C16 A D2 B E43
31 (RHD) 31 (RHD) 33 (RHD)
27 (LHD) 26 (LHD) 27 (LHD)
C23 A E34 E48
33 (RHD) 32 (RHD) 33 (RHD)
: Relay Blocks
Code See Page Relay Blocks (Relay Block Location)
2 23 Fuse Block Assembly (Lower Finish Panel)
57
AVANZA (EM19Y0E)
58
4
1
W–B W–B W
Ignition
–
+
C2
ECM
3
B
C23(A)
12 A
IG1
IGT
C1
Ignition Coil
Assembly No. 1
W–B
4
1
2
W–B W W W
–
2
+
(IG)
2 CE1
E/G
10A
3
R
11 A
IG2
IGT
W
C2
Ignition Coil
Assembly No. 2
W–B
4
1
W–B W
–
+
AVANZA (EM19Y0E)
3
G
10 A
IG3
IGT
W
C3
Ignition Coil
Assembly No. 3
4
1
W–B W
–
+
9 A
IG4
IGT
C4
Ignition Coil
Assembly No. 4
: Parts Location
Code See Page Code See Page Code See Page
25 (LHD) 25 (LHD) 27 (LHD)
C1 C3 C23 A
31 (RHD) 31 (RHD) 33 (RHD)
25 (LHD) 25 (LHD)
C2 C4
31 (RHD) 31 (RHD)
: Relay Blocks
Code See Page Relay Blocks (Relay Block Location)
2 23 Fuse Block Assembly (Lower Finish Panel)
: Ground Points
Code See Page Ground Points Location
36 (LHD)
C2 Engine Unit
40 (RHD)
59
AVANZA (EM19Y0E)
ECT and A/T Indicator and Engine Control
(IG) (BAT)
10A 15A
E/G EFI
B
2 2
2 1
L L L L L L
LG
W
L
W
1 1 1 1 2
Assembly No. 1
Assembly No. 2
Assembly No. 3
Assembly No. 4
9 AE4
Fuel Injector
Fuel Injector
Fuel Injector
Fuel Injector
W
Purge VSV
C20
C5
C6
C7
C8
LG
W
B
2 2 2 2 1
W
L
2 2 2 2
W–R
W
R
P
V
3 2 3 2
F/P Relay
EFI MAIN
Relay
4 A 3 A 2 A 1 A 24 A
5 1 5 1 # 10 # 20 # 30 # 40 PRG
C23(A), C24(B), E3(C)
ECM
2 2 2 2
FC2 FC1 SL IAHI IALO IBHI IBLO
17 C 18 C 23 C 15 A 14 A 17 A 16 A
W–L
L
W–B
B–W
B–W
(∗9)
(∗8)
5 JE1
G–W
(A/T)
B–W
B–W
(∗8)
(∗9)
BR
LG
W–L
P
1 CE1
4 PJ1
Junction Connector
L
L
W–L
4 3 1 4 2
IAHI IALO IBHI IBLO
E46
4 C19
+ Idle Speed Control
Actuator Assembly
Fuel Suction
M P1
Pump
E
L
5
W–B
3 PJ1
W–B
4
Connector
Junction
11 W–B
E39
(A/T)
J2 E4
60
AVANZA (EM19Y0E)
(BAT)
B
2
1
L
P
1 2 AE4
P
E25
5
Connector
2
Junction
C21
– VC PIM
E48
1 1 3 2 6
R
B
13
Connector
Junction
E42
R–W
LG
LG
G
B
P
L
12
G
7 A 7 C 6 A 5 A 35 B 17 B 12 B 12 C
+B1 BAT OCV+ OCV– E2PM VCPM PIM STP
C23(A), C24(B), E3(C)
ECM
AUX1 E21 THA THW VC VTHO E2 KNK
8 C 31 C 15 B 14 B 16 B 23 B 33 B 13 B
R–G
Junction Connector
(Shielded)
LG–R
G–W
B–W
L–R
BR
W
V
10 A
E40(A)
11 A
Throttle Position Sensor
Temperature Sensor
Temperature Sensor
1 1 1 3 2
G–W
VC PSW
Engine Coolant
Sensor (Bank 1)
Knock Control
Intake Air
2
C14
C15
C12
C13
–
2 2
Resistor
2 1
E1
1
BR
BR
BR
BR
BR BR BR BR
L L
(Shielded)
61
AVANZA (EM19Y0E)
ECT and A/T Indicator and Engine Control
(IG)
20A
(DEF)
L–B
(∗3)
Switch Assembly
C16(A) E27(B) C1 C2 C3 C4
Generator Power Steering Ignition Coil Ignition Coil Ignition Coil Ignition Coil
Assembly ECU Assembly Assembly No. 1 Assembly No. 2 Assembly No. 3 Assembly No. 4
E7
4
IG IDUP IGT IGT IGT IGT
(∗3)
2 A 8 B
P
3 3 3 3
11
Connector
Junction
E43
3
B–W
(∗3)
G
G
R
P
L
34 A 20 C 12 A 11 A 10 A 9 A 6 C
ALT EPS IG1 IG2 IG3 IG4 DEF
C23(A), C24(B), E3(C)
ECM
OX OXH1 N2+ N2– N+ N– OX2 OXH2
11 B 3 B 8 B 28 B 9 B 29 B 24 B 13 A
(∗6, ∗10)
W
(Shielded)
(Shielded)
(Shielded)
R–B
W
G
R
B
(Shielded)
(∗6, ∗10)
(∗6, ∗10)
(∗6, ∗10)
L–R
W
3 A 1 A (∗7) 1 1
(Bank 1 Sensor 1)
Crank Position
3 B 1 B (∗6)
Cam Position
C22(A), C26(B)
Oxygen Sensor
+ HTR–
3 1
Sensor
Sensor
(Bank 1 Sensor 2)
C10
+(∗6) IREL(∗6)
C9
E HTR+
2 2 OX2(∗10) OXH2(∗10) Oxygen Sensor
4 A 2 A (∗7)
4 B 2 B (∗6) E(∗6) ECHI(∗6)
C27
E2(∗10) +B(∗10)
4 2
BR
(∗6, ∗10)
(∗6, ∗10)
L
BR
BR
2 9 3
1 C25
Junction
Connector
8 4 11
BR
W–B
(Shielded)
BR
62
AVANZA (EM19Y0E)
(BAT) (ST) ∗ 1 : w/o Multi Information Display
∗ 2 : w/ Multi Information Display
∗ 3 : w/ Rear Window Defogger
10A 7. 5A ∗ 6 : Thailand
TAIL ST ∗ 7 : Except Thailand
∗10 : Mexico
2 2
B
1 (∗1) 2 (A/T)
(A/T)
V
B
1 AE4 L–W
2 (∗1)
L–W
(∗1)
(∗1)
V
1 5
13 A 10 A (LHD) E12
ST Relay
5 B 8 B (RHD) DLC3 13
(A/T)
L–W
L–W
(∗1)
LG
B L ECUT
Headlight Dimmer Switch Assembly
T ET 2 3
E40(A), E41(B)
Light Control
2 12 14 6
Junction
Switch
Tail
12 B
Head
E33(A), (B)
P–L
(∗1)
LG
B
10 C 25 C 26 C 1 C 2 C
H/L STA T LCAN HCAN
C23(A), C24(B), E3(C)
ECM
E1 E01 W SPD REV CANH CANL ATNE
32 B 7 B 27 C 22 C 33 C 4 C 3 C 24 C
W–B
W–B
(M/T ∗1)
(M/T ∗2)
(M/T ∗2)
(A/T ∗2)
(A/T ∗1)
(A/T ∗2)
(A/T ∗1)
LG–B
V–W
V–R
G
R
W–L
G
(A/T ∗1)
R
(A/T ∗1)
G(A/T ∗2)
R(A/T ∗2)
G(M/T ∗2)
R(M/T ∗2)
V–R
LG–B(M/T ∗1)
V–W
W–B
W–B
BR
C1
63
AVANZA (EM19Y0E)
ECT and A/T Indicator and Engine Control
(BAT)
10A
(ECU–B)
2
B
(A/T)
1
L–B
L–W
(∗1)
4 AE4
E40(A), E41(B)
15 A
Connector
Junction
L–B
E47
19 B Junction
7 Connector
13 14
(A/T)
(∗1)
V
24 A 16 A 2 A 1 A
T STR BAT BAT2
E9(A), E10(B)
Transmission Control ECU Assembly
BR
BR
W–L 8 2 9
(A/T ∗1)
(A/T ∗1)
(A/T ∗2)
(A/T ∗2)
LG
G
E45 E46 1
Junction Junction
11 9 Connector Connector
W–B
G
(A/T ∗1)
R 8 CE1
10 8 1 3
(A/T ∗1)
(A/T ∗2)
(A/T ∗2)
(A/T ∗2)
(A/T ∗2)
W
G
W–B
V–R V–R
V–W V–W
C2
64
AVANZA (EM19Y0E)
∗ 1 : w/o Multi Information Display
∗ 2 : w/ Multi Information Display
E20 E22
Transmission Revolution Transmission Revolution
Sensor (Turbine) Sensor (Output)
(Shielded)
G–W
B–W
L–W
W
R
9 B 20 B 10 B 21 B 7 B 18 B 8 B 19 B
VBTB ETBN RTBN EITB VBOP EOPT ROTP EIOP
E9(A), E10(B)
Transmission Control ECU Assembly
OTMP ETMP B1+ B1– C2+ C2– C3B+ C3B– LUCC LUCR SOLR
14 B 13 B 6 B 5 B 4 B 3 B 2 B 1 B 22 B 11 B 12 B
W–R
R–W
W–L
L–R
LG
W
G
R
P
8 12 7 11 5 9 6 10 2 3 4
H5 H9 H6 H10 H8 H12 H7 H11 H3 H2 H1
GR
BR
W
G
O
R
B
L
E21
ECT Solenoid (Solenoid Wire)
W(A/T ∗2) W(A/T ∗2)
V–R V–R
V–W V–W
65
AVANZA (EM19Y0E)
ECT and A/T Indicator and Engine Control
LG
B–Y
L
B–Y
LG
3 A 15 B 24 B
+B P N
E9(A), E10(B)
Transmission Control ECU Assembly
LG–B
W–R
L–W
L–W
G–B
G–Y
R–B
B–Y
(∗1)
(∗1)
(∗1)
V
L–W
R–B
G–Y
W–R
B–Y(∗1)
LG–B(∗1)
G–B(∗1)
L–W(A/T ∗1)
V–R V–R
V–W V–W
66
AVANZA (EM19Y0E)
L L
(IG)
+ P – N D 2 L E
7. 5A
IG1/BACK P
R
2
N
Park/Neutral Position
2
D
Switch Assembly
B–W
2
4
Connector
L
Junction
E23
E42
7 4 1 5 3 2 8 6
8
LG
R–W
E46
BR
R
B
L
Junction
Connector
Junction Connector
LG 14 13
5
7
B–Y 6
E46
Junction Connector
6 4
12
12
10
Junction Connector
E47
L
5 3
10
4
E46
W–G
R–Y
P–B
B–L
(∗1)
(∗1)
(∗1)
(∗1)
NSSD
P
3
Transmission
Transmission Floor
E47
Control
Switch
W–B
Junction
Shift Assembly
Connector 2
L–W B–L(∗1)
9 8
1 2
R–B R–Y(∗1)
W–R
(∗1)
G
G–Y P–B(∗1)
W–R G(∗1)
B–Y(∗1) B–Y(∗1)
LG–B(∗1) LG–B(∗1)
G–B(∗1) G–B(∗1)
V–R V–R
V–W V–W
11
E39
Junction
Connector
E4
67
AVANZA (EM19Y0E)
ECT and A/T Indicator and Engine Control
L
(IG)
(BAT)
10A
10A ECU IG2
BACK UP
2
2
2
1
(M/T)
(A/T)
B–W
LG
LG
2 2
Connector
Connector
Junction
Junction
8 AE4 L 8 8 W–G
E43
E48
(M/T ∗4)
9 9
B–W
(M/T)
(A/T)
R–L
R–L
E34
40 Combination Meter Assembly 39
+B IG
LCD
CPU
(∗1)
CAN IC
(M/T ∗1)
W–G
R–Y
P–B
B–Y
(∗1)
(∗1)
(∗1)
(∗1)
(∗1)
(∗1)
LG–R
G
R–B
W–G(∗1)
W(A/T ∗2)
G(M/T ∗2)
R(M/T ∗2)
E40(A), E41(B)
B(A/T ∗2)
R–Y(∗1) 6 B 3 B
Connector
Junction
P–B(∗1)
G(∗1) 5 A 9 A
B–Y(∗1)
(M/T ∗1)
LG–B
V–R
LG–B(∗1)
G–B(∗1) G–B(∗1)
B(A/T ∗2)
G(M/T ∗2)
R(M/T ∗2)
V–R
LG–B(M/T ∗1)
V–W V–W
68
AVANZA (EM19Y0E)
∗ 1 : w/o Multi Information Display
∗ 2 : w/ Multi Information Display
∗ 4 : w/o ABS
∗ 5 : w/ ABS
W–G
(M/T ∗4)
E34
Combination Meter Assembly
(M/T ∗4)
W–G
Check Engine
AT
CPU
B–W
B–R
V
(∗2)
Speedometer Sensor
3
(∗1) (∗2) IG 19 18 7 6
(∗2) FL1 FL0 FR1 FR0
(∗1)
(∗2)
SPDI E WNG EFI OUT GND VWOT RL1 RL0 RR1 RR0
E50
B10
12 16 31 37 1 2 22 5 4 17 16
(M/T ∗4)
(M/T ∗5)
R–W
V–W
L–W
G–B
(∗1)
BR
W
R
P
L
R–W(M/T ∗5)
L–W(M/T ∗4)
L–W(A/T ∗1)
17 BE4
(M/T ∗5)
R–W
W–B
G–B(∗1)
L–W
(A/T ∗1)
V–W
11
Connector
Junction
BR 5
E39
E4
69
AVANZA (EM19Y0E)
ECT and A/T Indicator and Engine Control
: Parts Location
Code See Page Code See Page Code See Page
24 (LHD) C19 31 (RHD) E22 32 (RHD)
B10
30 (RHD) 25 (LHD) 26 (LHD)
C20 E23
25 (LHD) 31 (RHD) 32 (RHD)
C1
31 (RHD) 25 (LHD) 26 (LHD)
C21 E25
25 (LHD) 31 (RHD) 32 (RHD)
C2
31 (RHD) 25 (LHD) 26 (LHD)
C22 A E27 B
25 (LHD) 31 (RHD) 32 (RHD)
C3
31 (RHD) 27 (LHD) A 26 (LHD)
C23 A E33
25 (LHD) 33 (RHD) B 32 (RHD)
C4
31 (RHD) 27 (LHD) 26 (LHD)
C24 B E34
25 (LHD) 33 (RHD) 32 (RHD)
C5
31 (RHD) 27 (LHD) 26 (LHD)
C25 E39
25 (LHD) 33 (RHD) 32 (RHD)
C6
31 (RHD) C26 B 31 (RHD) 27 (LHD)
E40 A
25 (LHD) 25 (LHD) 33 (RHD)
C7 C27
31 (RHD) 31 (RHD) 27 (LHD)
E41 B
25 (LHD) 26 (LHD) 33 (RHD)
C8 E1
31 (RHD) 32 (RHD) 27 (LHD)
E42
25 (LHD) 26 (LHD) 33 (RHD)
C9 E3 C
31 (RHD) 32 (RHD) 27 (LHD)
E43
25 (LHD) 26 (LHD) 33 (RHD)
C10 E7
31 (RHD) 32 (RHD) 27 (LHD)
E45
25 (LHD) 26 (LHD) 33 (RHD)
C11 E9 A
31 (RHD) 32 (RHD) 27 (LHD)
E46
25 (LHD) 26 (LHD) 33 (RHD)
C12 E10 B
31 (RHD) 32 (RHD) 27 (LHD)
E47
25 (LHD) 26 (LHD) 33 (RHD)
C13 E12
31 (RHD) 32 (RHD) 27 (LHD)
E48
25 (LHD) 26 (LHD) 33 (RHD)
C14 E18
31 (RHD) 32 (RHD) 27 (LHD)
E50
25 (LHD) 26 (LHD) 33 (RHD)
C15 E20
31 (RHD) 32 (RHD) 29 (LHD)
P1
25 (LHD) 26 (LHD) 35 (RHD)
C16 A E21
31 (RHD) 32 (RHD)
C19 25 (LHD) E22 26 (LHD)
: Relay Blocks
Code See Page Relay Blocks (Relay Block Location)
1 22 Engine Room R/B Assembly (Engine Compartment Right)
2 23 Fuse Block Assembly (Lower Finish Panel)
70
AVANZA (EM19Y0E)
: Ground Points
Code See Page Ground Points Location
36 (LHD)
C1
40 (RHD)
Engine Unit
36 (LHD)
C2
40 (RHD)
37 (LHD)
E4 Instrument Panel Reinforcement
41 (RHD)
38 (LHD)
J2 Center Body Pillar RH
42 (RHD)
71
AVANZA (EM19Y0E)
Engine Immobiliser System
E3(C)
ECM
2 2 2
2
1 2
SIO2
B
32 C
Un–Lock Warning
2
Switch Assembly
B–W
P–B
E57
1
13
Connector
8 AE4
Junction
G
E64
1
Connector
14
Junction
E64
LG–B
B–W
R–L
R–W
1 2 9 4
+B IG SIO2 KSW
E58
Transponder Key ECU Assembly
L–W
L–R
BR
LG
11
Connector
12 A 17 A
Junction
E40(A)
Door Control
IMO
Receiver
1 15 A 18 A
Transponder Key Coil
IND
E62
COL+
3
L–W
G–Y
R–G
COL–
E56
13 7
7
ECUT SIO
34
B
Security
E12
DLC3
Combination Meter
Assembly
E
E34
16
BR
10
5 E39
Junction
Connector
E4
72
AVANZA (EM19Y0E)
: Parts Location
Code See Page Code See Page Code See Page
26 (LHD) E39 32 (RHD) 27 (LHD)
E3 C E58
32 (RHD) 27 (LHD) 33 (RHD)
E40 A
26 (LHD) 33 (RHD) 27 (LHD)
E12 E62
32 (RHD) 27 (LHD) 33 (RHD)
E56
26 (LHD) 33 (RHD) 27 (LHD)
E34 E64
32 (RHD) 27 (LHD) 33 (RHD)
E57
E39 26 (LHD) 33 (RHD)
: Relay Blocks
Code See Page Relay Blocks (Relay Block Location)
1 22 Engine Room R/B Assembly (Engine Compartment Right)
2 23 Fuse Block Assembly (Lower Finish Panel)
: Ground Points
Code See Page Ground Points Location
37 (LHD)
E4 Instrument Panel Reinforcement
41 (RHD)
73
AVANZA (EM19Y0E)
DLC3
L–R
(∗4)
BACK UP
E9(A)
E34 Transmission B10
2 Combination Control ECU Brake Actuator
Transponder Key
Meter Assembly Assembly 10 Assembly
ECU Assembly
1 SIO
CPU T T TC SIO
E58
24 A 13 32 20
T
B–W
B–W
(∗4)
4
LG–B
V–W
G–R
P–B
(∗2)
(∗1)
(∗3)
(∗3)
V
E40(A), E41(B)
8 AE4 Junction
Junction Connector Connector 17 B 2 B
Power Steering
ECU Assembly
21 B 19 B SIO
E40(A), E41(B)
E27(B)
4 BE4 3 BE4 EPST
17 A 16 A 18 A 11 B
15 A 13 A 12 A
L–R
(∗4)
V–W
P–B
(∗3)
(∗3)
B–W
L–W
G–Y
L
E12
16 13 DLC3 7 3
+B ECUT SIO EPST
W–B
R–W
LG
26 C 1 C 2 C 7 A
E40(A)
T LCAN HCAN Junction
Connector
5 A
REV
33 C
W–B
E3(C)
ECM
V–R
8
E39
Junction
Connector
E4
74
AVANZA (EM19Y0E)
: Parts Location
Code See Page Code See Page Code See Page
24 (LHD) E12 32 (RHD) 27 (LHD)
B10 E40 A
30 (RHD) 26 (LHD) 33 (RHD)
E27 B
26 (LHD) 32 (RHD) 27 (LHD)
E3 C E41 B
32 (RHD) 26 (LHD) 33 (RHD)
E34
26 (LHD) 32 (RHD) 27 (LHD)
E9 A E58
32 (RHD) 26 (LHD) 33 (RHD)
E39
E12 26 (LHD) 32 (RHD)
: Relay Blocks
Code See Page Relay Blocks (Relay Block Location)
1 22 Engine Room R/B Assembly (Engine Compartment Right)
: Ground Points
Code See Page Ground Points Location
37 (LHD)
E4 Instrument Panel Reinforcement
41 (RHD)
75
AVANZA (EM19Y0E)
Headlight
B
1 1B
1 5
HEAD
Relay
2 3
B–W
12 AE4
B–W
P
12 A (LHD)
6 B (RHD) 2
B +
OFF Flash
Tail Low
Light
E
E34
Head High
16
B
E LO
HI
E33(A), (B) 11 A 8 A 9 A (LHD)
Headlight Dimmer 7 B 10 B 9 B (RHD)
Switch Assembly
FL MAIN
BR
2. 0L
P
B
W–B
P
Battery
P
5
E39
Junction
Connector
E3 E4
76
AVANZA (EM19Y0E)
1 1
10A 10A
H–LP LH H–LP RH
2 2
1 1
R
L
4 AE2
L
5 BE3
L
3 3
Assembly RH
Assembly LH
Headlight
Headlight
B4
A3
2 1 2 1
B
77
AVANZA (EM19Y0E)
Headlight
: Parts Location
Code See Page Code See Page Code See Page
24 (LHD) A 26 (LHD) 26 (LHD)
A3 E33 E39
30 (RHD) B 32 (RHD) 32 (RHD)
24 (LHD) 26 (LHD)
B4 E34
30 (RHD) 32 (RHD)
: Relay Blocks
Code See Page Relay Blocks (Relay Block Location)
1 22 Engine Room R/B Assembly (Engine Compartment Right)
: Ground Points
Code See Page Ground Points Location
37 (LHD)
E3
41 (RHD)
Instrument Panel Reinforcement
37 (LHD)
E4
41 (RHD)
78
AVANZA (EM19Y0E)
Memo
79
AVANZA (EM19Y0E)
Front Fog Light
(BAT) (BAT)
20A 10A
(FR FOG) TAIL
2 2
1 1
W–R
V
5 AE4 1 AE4
V
V
W–R
R
2 A 13 A (LHD)
1 B 5 B (RHD)
1 1 2 2 L B
7. 5A 7. 5A 3 2 FFG BFG T ET
Front Fog
(FR FOG LH) (FR FOG RH)
Light Control
Switch
OFF OFF
Light
FOG
Switch
2 2 Relay
On Tail
5 1 Head
2 2
2 2 B L
E33(A), (B) 4 A 10 A (LHD)
Headlight Dimmer 3 B 8 B (RHD)
V
Switch Assembly
G–W
L–R
V–W
LG
W–B
15 B
E40(A), E41(B)
Junction
Connector
4 BE3 11 AE3
21 A
G–W
L–R
Fog Light Assembly RH
Fog Light Assembly LH
2 2
1 1
B2
A5
W–B
W–B
10 BE3
W–B
4
Connector
Junction
E39
E1 A2 E4
80
AVANZA (EM19Y0E)
: Parts Location
Code See Page Code See Page Code See Page
24 (LHD) A 26 (LHD) 27 (LHD)
A5 E33 E40 A
30 (RHD) B 32 (RHD) 33 (RHD)
24 (LHD) 26 (LHD) 27 (LHD)
B2 E39 E41 B
30 (RHD) 32 (RHD) 33 (RHD)
: Relay Blocks
Code See Page Relay Blocks (Relay Block Location)
1 22 Engine Room R/B Assembly (Engine Compartment Right)
2 23 Fuse Block Assembly (Lower Finish Panel)
: Ground Points
Code See Page Ground Points Location
37 (LHD)
A2 Cowl Side Panel RH
41 (RHD)
37 (LHD)
E1
41 (RHD)
Instrument Panel Reinforcement
37 (LHD)
E4
41 (RHD)
81
AVANZA (EM19Y0E)
Turn Signal and Hazard Warning Light
(BAT) (IG)
10A 7. 5A
HAZARD IG1/BACK
2 2
2 2
G–W
B–W
L–W
B
Connector
Junction
E42
L–W
1
G–W
W–R
L–W
3 BE3
4 1 2 3
B L LR LL
L–W
L–W
(∗1)
(∗2)
E35
Turn Signal Flasher Assembly
EL ER EHW E
L–W
5 6 8 7
(∗1)
1
Headlight Assembly LH
W–B
B–R
B–Y
L–B
(∗4)
(∗3)
+
P
L–W
(∗1)
Front
Turn
6
Connector
Junction
5 1
7 A (LHD) –
E64
5 A +
B1
Light Assembly LH
Side Turn Signal
11 B 13 B (RHD) 12 2
Turn
Side
LH RH
B–R
(∗3)
(∗3)
R
TL TB TR –
B12
W–B
3 17
LH 2
Turn CHR
Signal
W–B
Assembly
(∗1)
Switch N
Warning
Hazard
Switch
Signal
E8
RH
4 E62
Door Control
RL+ Receiver
W–B
W–B
BR
W–B
BR
4 5
Connector
Junction
8
E39
E4 E1
82
AVANZA (EM19Y0E)
BR
L–W
G–W
Rear
Turn
5
3
W–B W–B L–W L–W
J2
15 JE2
–
+
J9
Rear Combination Light Assembly LH
Turn LH
5
L–W
+
Turn RH
16
BR G–W
E
∗
∗
∗
∗
E34
4
3
2
1
Side
Turn
2
1
W–B W–B G–W G–W
A2
–
+
(∗1) (∗1) (∗1) (∗1)
A9
Side Turn Signal
: w/ Wireless Door Lock Control
: w/ Front Side Turn Signal Light
(∗1)
Light Assembly RH G–W
AVANZA (EM19Y0E)
W–B
(∗1) Front
Turn
2
1
A1
10 AE3
–
+
(∗2)
A2
Headlight Assembly RH
Rear
Turn
5
3
J1
16 JE2
–
+
J4
Rear Combination Light Assembly RH
83
Turn Signal and Hazard Warning Light
: Parts Location
Code See Page Code See Page Code See Page
24 (LHD) A 26 (LHD) 27 (LHD)
A2 E33 E62
30 (RHD) B 32 (RHD) 33 (RHD)
24 (LHD) 26 (LHD) 27 (LHD)
A9 E34 E64
30 (RHD) 32 (RHD) 33 (RHD)
24 (LHD) 26 (LHD) 29 (LHD)
B1 E35 J4
30 (RHD) 32 (RHD) 35 (RHD)
24 (LHD) 26 (LHD) 29 (LHD)
B12 E39 J9
30 (RHD) 32 (RHD) 35 (RHD)
26 (LHD) 27 (LHD)
E8 E42
32 (RHD) 33 (RHD)
: Relay Blocks
Code See Page Relay Blocks (Relay Block Location)
2 23 Fuse Block Assembly (Lower Finish Panel)
: Ground Points
Code See Page Ground Points Location
37 (LHD)
A1
41 (RHD)
Cowl Side Panel RH
37 (LHD)
A2
41 (RHD)
37 (LHD)
E1
41 (RHD)
Instrument Panel Reinforcement
37 (LHD)
E4
41 (RHD)
38 (LHD)
J1 Quarter Panel RH
42 (RHD)
38 (LHD)
J2 Center Body Pillar RH
42 (RHD)
84
AVANZA (EM19Y0E)
Memo
85
AVANZA (EM19Y0E)
86
Back-Up Light
R
7
8
4
2
LG B–W
2
+
(IG)
(A/T)
1
2
1
V–W P E42
–
(A/T) (A/T) Junction
Connector
7. 5A
E47 E23
Junction Park/Neutral Position
IG1/BACK
Back–Up
5
4
2
1
W–B V–W V–W V–W LG
J2
17 JE2
–
+
(M/T) (M/T)
E49
J9 Back–Up Light Switch Assembly
Rear Combination
Light Assembly LH
V–W
AVANZA (EM19Y0E)
Back–Up
5
4
W–B V–W
J1
–
+
J4
Rear Combination
Light Assembly RH
: Parts Location
Code See Page Code See Page Code See Page
26 (LHD) 27 (LHD) 29 (LHD)
E23 E47 J4
32 (RHD) 33 (RHD) 35 (RHD)
27 (LHD) 27 (LHD) 29 (LHD)
E42 E49 J9
33 (RHD) 33 (RHD) 35 (RHD)
: Relay Blocks
Code See Page Relay Blocks (Relay Block Location)
2 23 Fuse Block Assembly (Lower Finish Panel)
: Ground Points
Code See Page Ground Points Location
38 (LHD)
J1 Quarter Panel RH
42 (RHD)
38 (LHD)
J2 Center Body Pillar RH
42 (RHD)
87
AVANZA (EM19Y0E)
88
Stop Light
Stop
2
2
1
6
5
2
14
13
L–R L–R L–R B R P P
1
9 JE1
5
2 AE4
W–B
+
(BAT)
J2
–
E42 E48
E25
Junction Junction
10A
Connector Connector
STOP
Tail
Stop Light
J9
Switch Assembly
Rear Combination
L–R
Light Assembly LH
BR
Stop
2
L–R L–R
5
5 MJ1
W–B W–B
+
(∗1)
J1
–
W–B
Tail
J4
Rear Combination
AVANZA (EM19Y0E)
1
Light Assembly RH
MJ1
(∗1)
L–R
W–B
∗ 1 : w/ Center Stop Light
∗ 2 : w/o Center Stop Light
(∗2)
(∗1)
W–B
2
1
W–B W–B W–B L–R
L1
1 ML1
–
+
(∗1) (∗1) (∗1)
M1
Center Stop Light Assembly
: Parts Location
Code See Page Code See Page Code See Page
26 (LHD) 27 (LHD) 29 (LHD)
E25 E48 J9
32 (RHD) 33 (RHD) 35 (RHD)
27 (LHD) 29 (LHD) 29 (LHD)
E42 J4 M1
33 (RHD) 35 (RHD) 35 (RHD)
: Relay Blocks
Code See Page Relay Blocks (Relay Block Location)
1 22 Engine Room R/B Assembly (Engine Compartment Right)
: Ground Points
Code See Page Ground Points Location
38 (LHD)
J1 Quarter Panel RH
42 (RHD)
38 (LHD)
J2 Center Body Pillar RH
42 (RHD)
38 (LHD)
L1 Back Door Panel
42 (RHD)
89
AVANZA (EM19Y0E)
Illumination and Taillight
2 2 2
1 1 2
V
LG
1 AE4
(M/T)
(A/T)
B–W
LG
LG
2 2
Connector
Connector
Junction
Junction
E48
E43
8 AE4
LG
V
9 9
LG
(M/T)
(A/T)
B–W
R–L
R–L
13 A 10 A (LHD)
5 B 8 B (RHD) 40 39 14
B L +B IG ILM+
T ET
OFF
Control
Switch
Light
Tail Illumination
Illumination
Pointer
Head
LCD
E34
16
BR
BR
90
AVANZA (EM19Y0E)
LG
BR
LG
5
G–Y
21 A
13 B
LG
6
5
2
1
14
BR W–B R–B
19 A
–
+
(∗1) (∗1) (∗1)
E43
Junction E7
Connector Rear Window Defogger
Switch Assembly
2
2
1
W–B P–L
20 A
–
+
E59
Ash Receptacle
Light Sub–Assembly
3
6
3
11
11
W–B GR W–L P–B
22 A
14 B
(A/T) (A/T) (A/T) (∗2)
ILL–
ILL+
E46 E40(A), E41(B)
Junction Junction Connector
Connector
E18
Transmission Floor
Shift Assembly
AVANZA (EM19Y0E)
4
2
1
W–B W–B LG
E4
–
+
E39
E8
Hazard Warning Signal
Junction
LG
Connector
Switch Assembly
2
3
W–B LG
E
∗ 2 : w/ Steering Pad Switch
E14
∗ 1 : w/ Rear Window Defogger
(∗2)
P–B
G–Y
91
Illumination and Taillight
LG LG
G–Y
LG
P–B
(∗2)
8 BE3
G–Y
P–B
(∗2)
LG
W–G
(∗2)
Sub–Assembly
E32(A), z3(B)
Spiral Cable
2 A 5 A
IL+2 EAU
1
Headlight Assembly LH
6 B 10 A
2 B 5 B EAU ILM+ +
Stereo Component
Tuner Assembly
Clearance
E4(A), E5(B)
Steering
Pad Switch
E –
B3
z3(B) 7 A 2
Steering Wheel
Sub–Assembly
W–B
W–B
10 BE3
W–B
W–B
E1
92
AVANZA (EM19Y0E)
LG
Stop
5
W–B
J2
1
–
LG LG LG
10 JE1
+
Tail
LG
J9
Rear Combination Light Assembly LH
LG
Stop
5
W–B
J1
1
–
LG
+
Tail
J4
Rear Combination Light Assembly RH
2
1
W–B LG LG LG LG
L1
3 MJ1
3 ML1
L3
License Plate
AVANZA (EM19Y0E)
Light Assembly LH
∗ 2 : w/ Steering Pad Switch
2
1
W–B LG
L2
License Plate
Light Assembly RH
W–B
A2
Clearance
2
1
W–B W–B LG LG
A1
9 AE3
–
+
A4
Headlight Assembly RH
93
Illumination and Taillight
: Parts Location
Code See Page Code See Page Code See Page
24 (LHD) E18 32 (RHD) 27 (LHD)
A4 E46
30 (RHD) 26 (LHD) 33 (RHD)
E32 A
24 (LHD) 32 (RHD) 27 (LHD)
B3 E48
30 (RHD) A 26 (LHD) 33 (RHD)
E33
26 (LHD) B 32 (RHD) 27 (LHD)
E4 A E59
32 (RHD) 26 (LHD) 33 (RHD)
E34
26 (LHD) 32 (RHD) 29 (LHD)
E5 B J4
32 (RHD) 26 (LHD) 35 (RHD)
E39
26 (LHD) 32 (RHD) 29 (LHD)
E7 J9
32 (RHD) 27 (LHD) 35 (RHD)
E40 A
26 (LHD) 33 (RHD) 29 (LHD)
E8 L2
32 (RHD) 27 (LHD) 35 (RHD)
E41 B
26 (LHD) 33 (RHD) 29 (LHD)
E14 L3
32 (RHD) 27 (LHD) 35 (RHD)
E43
E18 26 (LHD) 33 (RHD) z3 B 27 (LHD)
: Relay Blocks
Code See Page Relay Blocks (Relay Block Location)
1 22 Engine Room R/B Assembly (Engine Compartment Right)
2 23 Fuse Block Assembly (Lower Finish Panel)
: Ground Points
Code See Page Ground Points Location
37 (LHD)
A1
41 (RHD)
Cowl Side Panel RH
37 (LHD)
A2
41 (RHD)
37 (LHD)
E1
41 (RHD)
Instrument Panel Reinforcement
37 (LHD)
E4
41 (RHD)
38 (LHD)
J1 Quarter Panel RH
42 (RHD)
38 (LHD)
J2 Center Body Pillar RH
42 (RHD)
38 (LHD)
L1 Back Door Panel
42 (RHD)
94
AVANZA (EM19Y0E)
Memo
95
AVANZA (EM19Y0E)
Interior Light
(BAT)
10A
BACK UP
B–W
∗ 1 : w/ Door Indicator Light
∗ 2 : w/o Door Indicator Light
∗ 3 : w/ Wireless Door Lock Control
8 AE4
∗ 4 : w/o Wireless Door Lock Control
∗ 5 : w/ Glasses Case
∗ 6 : w/o Glasses Case
∗ 7 : Except Malaysia
B–W
40
+B
(∗1)
(∗2)
Door
L CTY
E34
1 21
W–L
(∗4)
(∗3)
W
W
4 MJ1 18 JE2
4
W–L
W–L
Door Control
CTY
W–L
RMLP Receiver
E62
W–L
W–L
W–L
W–L
W–L
(∗3)
4 1 1 1 1
Light Switch RH
Light Switch RH
Light Switch LH
Light Switch LH
Lock Assembly
Front Courtesy
Front Courtesy
Rear Courtesy
Rear Courtesy
Back Door
W–L
(∗3)
L4
J1
J6
J3
J8
W
W–B
(∗4)
L1
96
AVANZA (EM19Y0E)
W
(∗4)
(∗3)
W–L
K4
Map Light Assembly
7
6
W–B L
–
+
(∗5) (∗5)
1
W–L
DR
(∗5)
2
W–L B
DOOR
9 KE1
(∗6) R
DR
1
OFF
+
(∗6)
ON
–
K1
BR W–B W–B Map Light Assembly
E3
4 KE1
(∗6)
1
W–L
DOOR
2
5
2
12
LG LG LG P P
W–B
(∗7)
1
DR
10 KE1
2 AE4
OFF
+
(BAT)
(∗7)
ON
E48
8
K2 Junction
10A
E4
No. 1 Room Light Assembly Connector
STOP
E39
Junction
Connector
AVANZA (EM19Y0E)
97
Interior Light
: Parts Location
Code See Page Code See Page Code See Page
26 (LHD) 29 (LHD) 29 (LHD)
E34 J1 K1
32 (RHD) 35 (RHD) 35 (RHD)
26 (LHD) 29 (LHD) 29 (LHD)
E39 J3 K2
32 (RHD) 35 (RHD) 35 (RHD)
27 (LHD) 29 (LHD) 29 (LHD)
E48 J6 K4
33 (RHD) 35 (RHD) 35 (RHD)
27 (LHD) 29 (LHD) 29 (LHD)
E62 J8 L4
33 (RHD) 35 (RHD) 35 (RHD)
: Relay Blocks
Code See Page Relay Blocks (Relay Block Location)
1 22 Engine Room R/B Assembly (Engine Compartment Right)
: Ground Points
Code See Page Ground Points Location
37 (LHD)
E3
41 (RHD)
Instrument Panel Reinforcement
37 (LHD)
E4
41 (RHD)
38 (LHD)
L1 Back Door Panel
42 (RHD)
98
AVANZA (EM19Y0E)
Memo
99
AVANZA (EM19Y0E)
ABS
Switch Assembly
2 2 2 2
Stop Light
E25
1 1 2 1
2
W–R
P
W–R
Junction Connector
P
B
E40(A), E41(B)
9 B 2 AE4
13
Connector
Junction
E42
3 AE2 1 AE2
R
P
3 A 6
Connector
W–G
W–R
G–Y
Junction
P
E48
6
1 BE1 2 BE1 (RHD) 5 BE4 16 BE4
1 BE5 2 BE5 (LHD)
W–G
W–R
P
G–Y
B10
12 24 34 Brake Actuator Assembly 28
+BS +BM +IG STP
FL1 FL0 FR1 FR0 RL1 RL0 RR1 RR0 GND1 GND2
19 18 7 6 5 4 17 16 1 13
W–B
W–B
B–W
B–R
LG
W
R
V
P
L
B–R
W
R
P
L
B–R
W
R
P
L
Front Speed Sensor RH
2 2 2 2
– – – –
+ + + +
B11
A8
J7
J2
1 1 1 1
B1
100
AVANZA (EM19Y0E)
W–B W–B
E1
10 BE3
(LHD) (LHD)
E12
DLC3
20
P–B P–B G–Y
16 A
18 A
SIO
SIO
3 BE4
2
1
B B
–
+
32
13
7 BE3
(LHD) (LHD) V–W V–W L–W
13 A
15 A
TC
4 BE4
ECUT
B13
Brake Fluid Level Warning Switch E40(A)
(Brake Master Cylinder Junction
Reservoir Sub–Assembly) Connector
B10
2
1
30
W–B B B LG–R LG–R
–
+
10 B
1 A
A1
12 AE3
2 BE4
PKB
(RHD) (RHD) (RHD)
A7
Brake Fluid Level Warning Switch
(Brake Master Cylinder
2 A
Reservoir Sub–Assembly)
1
W–R W–R
14 JE2
J5
21
Parking Brake Switch V–R V–R
WA
15 BE4
23
B B
1 BE4
BRL
8
B
AVANZA (EM19Y0E)
2
40
–
B–W B–W
1
8 AE4
CPU
(BAT)
+B
10A
Brake
BACK UP
9
2
2
18
39
V–R R–L LG
2
(IG)
– (A/T) (A/T)
IG
E43
ABS Junction
10A
Connector
5
16
BR
E4
E
ECU IG2
9
2
E39 R–L LG
Junction Connector (M/T) (M/T)
E34 E48
Combination Meter Assembly Junction
Connector
101
ABS
: Parts Location
Code See Page Code See Page Code See Page
A7 30 (RHD) E25 32 (RHD) 27 (LHD)
E43
24 (LHD) 26 (LHD) 33 (RHD)
A8 E34
30 (RHD) 32 (RHD) 27 (LHD)
E48
24 (LHD) 26 (LHD) 33 (RHD)
B10 E39
30 (RHD) 32 (RHD) 29 (LHD)
J2
24 (LHD) 27 (LHD) 35 (RHD)
B11 E40 A
30 (RHD) 33 (RHD) 29 (LHD)
J5
B13 24 (LHD) 27 (LHD) 35 (RHD)
E41 B
26 (LHD) 33 (RHD) 29 (LHD)
E12 J7
32 (RHD) 27 (LHD) 35 (RHD)
E42
E25 26 (LHD) 33 (RHD)
: Relay Blocks
Code See Page Relay Blocks (Relay Block Location)
1 22 Engine Room R/B Assembly (Engine Compartment Right)
2 23 Fuse Block Assembly (Lower Finish Panel)
: Ground Points
Code See Page Ground Points Location
A1 41 (RHD) Cowl Side Panel RH
37 (LHD)
B1 Cowl Side Panel LH
41 (RHD)
E1 37 (LHD)
37 (LHD) Instrument Panel Reinforcement
E4
41 (RHD)
102
AVANZA (EM19Y0E)
SRS
NOTICE : When inspecting or repairing the SRS, perform service in accordance with the following precautionary instructions
and the procedure, and precautions in the Repair Manual applicable for the model year.
● Malfunction symptoms of the SRS are difficult to confirm, so the DTCs become the most important source of information
when troubleshooting. When troubleshooting the SRS, always inspect the DTCs before disconnecting the battery.
● Work must be started more than 90 seconds after the ignition or starter switch assembly is turned to the ”LOCK”
position and the negative (-) terminal cable is disconnected from the battery.
(The SRS is equipped with a back-up power source so that if work is started within 90 seconds from disconnecting
the negative (-) terminal cable of the battery, the SRS may deploy.)
● When the negative (-) terminal cable is disconnected from the battery, the memory of the clock and audio system will be
cleared. So before starting work, make a record of the contents in the audio memory system. When work is finished, reset
the audio systems as they were before and adjust the clock. Some vehicles have power tilt steering, power telescopic
steering, power seat and power outside rear view mirror which are all equipped with memory function. However, it is not
possible to make a record of these memory contents. So when the work is finished, it will be necessary to explain it to your
customer, and ask the customer to adjust the features and reset the memory. To avoid erasing the memory in each system,
never use a back-up power supply from outside the vehicle.
● Before repair, remove the airbag sensor if shocks are likely to be applied to the sensor during repair.
● Even in cases of a minor collision where the SRS does not deploy, the following parts should be inspected;
● Never use SRS parts from another vehicle. When replacing parts, replace with new parts.
● For the purpose of reuse, never disassemble and repair the following parts.
● If the following parts have been dropped, or have cracks, dents and other defects in their case, bracket, and connector,
replace with new one.
● Use a volt/ohmmeter with high impedance (10 kΩ/V minimum) for troubleshooting electrical circuits of the system.
● Information labels are attached to the periphery of the SRS components. Follow the instructions of the notice.
● After work on the SRS is completed, check the SRS warning light.
● If the vehicle is equipped with a mobile communication system, refer to the precaution in the IN section of the Repair Manual.
103
AVANZA (EM19Y0E)
SRS
(IG)
7. 5A
ECU IG1
1
W–R
J14 J13
Front Seat Outer Front Seat Outer
Belt Assembly LH Belt Assembly RH
E40(A), E41(B)
9 B
Pretensioner Pretensioner
Connector
Junction
4 A P– P+ D– D+
1 2 1 2
Y–G
Y–R
Y–B
(∗4)
(∗4)
(∗4)
(∗4)
P
Y–G
Y–R
Y–B
(∗4)
(∗4)
(∗4)
(∗4)
P
9 A 7 B 8 B 6 B 5 B
IG1 PPC PPH PDC PDH
E60(A), E66(B)
Airbag ECU Assembly
E1 D+ D– AP+ AP–
19 A 4 A 3 A 1 A 2 A
W–B
Y–B
Y
6 EE2 1 A 2 A (∗2)
Y–G
Y–R
1 B 2 B (∗1)
E55(A), E63(B), z5(C)
D+ D–
Spiral Cable
Sub–Assembly
2 C 1 C
1 2
P+ P–
W–B
z5(C)
Driver Side Squib Circuit E61
(Horn Button Assembly) Airbag Squib
(Instrument Panel
Passenger Airbag
Assembly)
3
Connector
Junction
E39
E4
104
AVANZA (EM19Y0E)
∗ 1 : w/ Steering Pad Switch
∗ 2 : w/o Steering Pad Switch
∗ 3 : w/ Multi Information Display
∗ 4 : w/ Pretensioner
A11 B14
Front Airbag Front Airbag
Sensor RH Sensor LH
LG
W
R
LG
W
R
12 A 13 A 14 A 20 A
SR+ SR– SL+ SL–
E60(A), E66(B)
Airbag ECU Assembly
LA T SIL GSW2
21 A 10 A 17 A 18 A
G–W
B–W
V
B–W
L
V
13 C
FPOF
E40(A), E41(B)
20 B 16 B
Connector
Junction
E3(C)
15 A 18 A ECM
L–W
G–Y
13 7
ECUT SIO
E12
DLC3
V
105
AVANZA (EM19Y0E)
SRS
(IG)
10A
ECU IG2 ∗ 3 : w/ Multi Information Display
LG
(A/T)
(M/T)
LG
2 2
Connector
Connector
Junction
Junction
E48
E43
9 9
(M/T)
R–L
R–L
(A/T)
39
IG
Combination Meter Assembly
SRS
A/B E
E34
17 16
V
BR
5
E39
V Junction
Connector
E4
106
AVANZA (EM19Y0E)
: Parts Location
Code See Page Code See Page Code See Page
24 (LHD) E39 32 (RHD) 27 (LHD)
A11 E60 A
30 (RHD) 27 (LHD) 33 (RHD)
E40 A
24 (LHD) 33 (RHD) 27 (LHD)
B14 E61
30 (RHD) 27 (LHD) 33 (RHD)
E41 B
26 (LHD) 33 (RHD) 27 (LHD)
E3 C E63 B
32 (RHD) 27 (LHD) 33 (RHD)
E43
26 (LHD) 33 (RHD) E66 B 33 (RHD)
E12
32 (RHD) 27 (LHD) J13 35 (RHD)
E48
26 (LHD) 33 (RHD) J14 35 (RHD)
E34
32 (RHD) 27 (LHD) 27 (LHD)
E55 A z5 C
E39 26 (LHD) 33 (RHD) 33 (RHD)
: Relay Blocks
Code See Page Relay Blocks (Relay Block Location)
1 22 Engine Room R/B Assembly (Engine Compartment Right)
2 23 Fuse Block Assembly (Lower Finish Panel)
: Ground Points
Code See Page Ground Points Location
37 (LHD)
E4 Instrument Panel Reinforcement
41 (RHD)
107
AVANZA (EM19Y0E)
EPS
2 2
G–Y
B
Junction Connector
Junction Connector
B
E40(A), E41(B)
18 A
3 AE1 9 B
E41(B)
8 B 17 B
B
R
B
W
LG–B
W–L
B–R
B–Y
P
(RHD)
(RHD)
R
B
(LHD)
(LHD)
M
R
B
z2(D)
Power Steering Torque Sensor
(Steering Column Assembly)
z1(C)
Power Steering Motor
(Steering Column Assembly)
P
W–B
B–Y
B–R
W–L
E5
108
AVANZA (EM19Y0E)
C24(B), E3(C)
ECM
G
(M/T ∗2)
V–R
W
B
(Shielded)
(A/T ∗2)
(A/T ∗2)
B
(M/T ∗2)
W
(A/T ∗1)
(A/T ∗1)
G
R
B
G
R
R
W
E45
Junction
8 10 Connector
E40(A), E41(B)
5 A 1
Crank Position
Connector
Junction
Sensor
9 11 1 3
C10
5 B
2
(A/T ∗2)
(A/T ∗2)
(A/T ∗2)
(A/T ∗2)
LG
W
P
B
B–Y
9
Connector
Junction
C25
4 7 A 17 A
CANH CANL
SPD0
E9(A) 11 A
P Transmission
Control ECU
Assembly
(A/T ∗1)
B–Y
L–W
W(A/T ∗2)
BR
B(A/T ∗2)
R(M/T ∗2)
B–R B–R
L–W(A/T ∗1)
W–L W–L
C1
109
AVANZA (EM19Y0E)
EPS
G
(M/T ∗2)
W–G
(M/T ∗4)
(M/T ∗4)
W–G
B–W
B–R
LG
B10
Brake Actuator
19 18 7 6 Assembly
FL1 FL0 FR1 FR0
Speedometer Sensor
3
5 4 17 16 22
IG
W
R
P
L
(M/T ∗3)
R–W
GND OUT
E50
2 1
(M/T ∗4)
W–B
L–W
G(M/T ∗2)
B–R B–R
L–W(M/T ∗4)
R–W(M/T ∗3)
W–L W–L
W–B
(M/T ∗4)
110
AVANZA (EM19Y0E)
B–R
W–L
W–B
W–G
(M/T ∗4)
(M/T ∗4)
B(A/T ∗2)
R(M/T ∗2)
W(A/T ∗2)
G(M/T ∗2)
L–W(A/T ∗1)
L–W(M/T ∗4)
R–W(M/T ∗3)
Power
8
Steering
9
2
2
15
39
B–R R–L LG
2
(IG)
(M/T) (M/T)
IG
E48
EPSW
Junction
10A
G Connector
ECU IG2
(M/T ∗2)
9
2
R–L LG
29
W (A/T) (A/T)
(A/T ∗2) E43
Junction
CANL
Connector
CAN IC
28
B
(A/T ∗2)
CANH
R
(M/T ∗2)
L–W
(M/T ∗4)
12
R–W R–W
CPU
17 BE4
(M/T ∗3) (M/T ∗3)
SPDI
(∗1)
AVANZA (EM19Y0E)
L–W
(A/T ∗1)
13
W–L LG–R
4 B
3 B
(∗2)
E41(B)
SPSR
Junction
Connector
11
5
2
16
40
BR B–W B–W
1
E4
8 AE4
E
(BAT)
+B
E39
Junction
10A
Connector
E34
BACK UP
111
EPS
: Parts Location
Code See Page Code See Page Code See Page
24 (LHD) E12 32 (RHD) 27 (LHD)
B10 E43
30 (RHD) 26 (LHD) 33 (RHD)
E26 A
25 (LHD) 32 (RHD) 27 (LHD)
C10 E45
31 (RHD) 26 (LHD) 33 (RHD)
E27 B
27 (LHD) 32 (RHD) 27 (LHD)
C24 B E48
33 (RHD) 26 (LHD) 33 (RHD)
E34
27 (LHD) 32 (RHD) 27 (LHD)
C25 E50
33 (RHD) 26 (LHD) 33 (RHD)
E39
26 (LHD) 32 (RHD) 27 (LHD)
E3 C z1 C
32 (RHD) 27 (LHD) 33 (RHD)
E40 A
26 (LHD) 33 (RHD) 27 (LHD)
E9 A z2 D
32 (RHD) 27 (LHD) 33 (RHD)
E41 B
E12 26 (LHD) 33 (RHD)
: Relay Blocks
Code See Page Relay Blocks (Relay Block Location)
1 22 Engine Room R/B Assembly (Engine Compartment Right)
2 23 Fuse Block Assembly (Lower Finish Panel)
: Ground Points
Code See Page Ground Points Location
36 (LHD)
C1 Engine Unit
40 (RHD)
37 (LHD)
E4
41 (RHD)
Instrument Panel Reinforcement
37 (LHD)
E5
41 (RHD)
112
AVANZA (EM19Y0E)
Memo
113
AVANZA (EM19Y0E)
Remote Control Mirror
(ACC)
10A
ACC
L
E36
Outer Mirror Switch Assembly 8
B
Operation
Switch
Right/
Down
Down
Right
Left/
Left
Up
Up
Switch
Select
HL HR VL VR C E
5 2 4 3 6 7
G–W
R–W
W–B
LG
V
R–W
G–W
R–W
R–W
LG
V
LG(RHD)
B(RHD)
V(LHD)
G–W
R–W
R–W
V
1 5 3 5 1 3
H V C V H C
M M M M
G2 F2
Outer Rear View Outer Rear View
Mirror Assembly LH Mirror Assembly RH
8
Connector
Junction
E39
E4
114
AVANZA (EM19Y0E)
: Parts Location
Code See Page Code See Page Code See Page
26 (LHD) E39 32 (RHD) 28 (LHD)
E36 G2
32 (RHD) 28 (LHD) 34 (RHD)
F2
E39 26 (LHD) 34 (RHD)
: Relay Blocks
Code See Page Relay Blocks (Relay Block Location)
2 23 Fuse Block Assembly (Lower Finish Panel)
: Ground Points
Code See Page Ground Points Location
37 (LHD)
E4 Instrument Panel Reinforcement
41 (RHD)
115
AVANZA (EM19Y0E)
116
E19
SLS+
Shift Lock
Solenoid
Shift Lock
SLS–
8
1
2
2
V–W LG
2
P
IG
(IG)
E43
Junction
10A
Connector
ECU IG2
E2
6
8
2
2
G L
2
ACC
(ACC)
1
2
5
BR R–W E48
KS0–
KS0+
KLS+
Junction
10A
ACC
Connector
E29
Key Inter Lock Solenoid
AVANZA (EM19Y0E)
(Steering Column Upper with
Switch Bracket Assembly)
6
5
2
P P
1
2 AE4
(BAT)
E48
Junction
10A
Connector
STOP
6
BR
R
6
1
4
5
2
1
14
13
13
BR GR L–W B
E
E4
STP
: Relay Blocks
Code See Page Relay Blocks (Relay Block Location)
1 22 Engine Room R/B Assembly (Engine Compartment Right)
2 23 Fuse Block Assembly (Lower Finish Panel)
: Ground Points
Code See Page Ground Points Location
37 (LHD)
E4 Instrument Panel Reinforcement
41 (RHD)
117
AVANZA (EM19Y0E)
118
2
1
W–B L–R
Seat Belt Warning
(RHD) (RHD)
J15
Front Seat Inner
Belt Assembly RH
2
1
2
35
40
W–B L–R L–R B–W B–W
1
J1
5 JE2
8 AE4
(BAT)
(LHD) (LHD)
+B
J10
DBLT
Front Seat Inner
10A
Belt Assembly LH
BACK UP
9
2
2
39 R–L LG
2
CPU
(IG)
IG (M/T) (M/T)
E48
Junction
10A
Connector
ECU IG2
LG
R–L
(A/T)
(A/T)
9
2
AVANZA (EM19Y0E)
Driver' s
Seat Belt
5
16
BR E43
E4
E
Junction
Connector
E39
Junction Connector
E34
Combination Meter Assembly
: Parts Location
Code See Page Code See Page Code See Page
26 (LHD) 27 (LHD) J10 29 (LHD)
E34 E43
32 (RHD) 33 (RHD) J15 35 (RHD)
26 (LHD) 27 (LHD)
E39 E48
32 (RHD) 33 (RHD)
: Relay Blocks
Code See Page Relay Blocks (Relay Block Location)
1 22 Engine Room R/B Assembly (Engine Compartment Right)
2 23 Fuse Block Assembly (Lower Finish Panel)
: Ground Points
Code See Page Ground Points Location
37 (LHD)
E4 Instrument Panel Reinforcement
41 (RHD)
38 (LHD)
J1 Quarter Panel RH
42 (RHD)
119
AVANZA (EM19Y0E)
120
Light
Control
Switch
E33(A), (B)
B
2
V V
5 B
13 A
Tail
1 AE4
OFF
Head
(BAT)
Switch Assembly
Headlight Dimmer
T
10A
TAIL
L
LG
ET
10 A (LHD)
8 B (RHD)
3
4
W–B W–L W–L
L1
6 ML1
L4
Back Door
Lock Assembly
1
W–L W–L
Key Reminder and Light Reminder
4 MJ1
J1
Front Courtesy
Light Switch RH
W–L
1
W–L
J6
Front Courtesy
AVANZA (EM19Y0E)
Light Switch LH
W–L
1
W–L
J3
Rear Courtesy
Light Switch RH
W–L
1
W–L W–L W–L
18 JE2
J8
Rear Courtesy
Light Switch LH
LG
W–L
LG
W–L
5
16
BR
E4
E
1
E39
Buzzer
L
Junction Connector
14
ILM+
CPU
2
30
40
L–B B–W B–W
1
8 AE4
(BAT)
+B
KEY
10A
BACK UP
9
2
2
39
R–L LG
2
(IG)
(M/T) (M/T)
IG
E48
Junction
10A
Connector
E34
ECU IG2
R–L
(A/T)
(A/T)
AVANZA (EM19Y0E)
9
2
E43
Junction
Connector
9
1
1
2
2
L–B G B
2
(BAT)
E64 E57
Junction Un–Lock Warning
10A
121
Key Reminder and Light Reminder
: Parts Location
Code See Page Code See Page Code See Page
A 26 (LHD) 27 (LHD) 29 (LHD)
E33 E48 J3
B 32 (RHD) 33 (RHD) 35 (RHD)
26 (LHD) 27 (LHD) 29 (LHD)
E34 E57 J6
32 (RHD) 33 (RHD) 35 (RHD)
26 (LHD) 27 (LHD) 29 (LHD)
E39 E64 J8
32 (RHD) 33 (RHD) 35 (RHD)
27 (LHD) 29 (LHD) 29 (LHD)
E43 J1 L4
33 (RHD) 35 (RHD) 35 (RHD)
: Relay Blocks
Code See Page Relay Blocks (Relay Block Location)
1 22 Engine Room R/B Assembly (Engine Compartment Right)
2 23 Fuse Block Assembly (Lower Finish Panel)
: Ground Points
Code See Page Ground Points Location
37 (LHD)
E4 Instrument Panel Reinforcement
41 (RHD)
38 (LHD)
L1 Back Door Panel
42 (RHD)
122
AVANZA (EM19Y0E)
Memo
123
AVANZA (EM19Y0E)
Door Lock Control (LHD)
15A
(D/L)
B
(∗2)
2
L
2 (∗2)
(∗2)
(∗2)
(∗2)
R
L
E24
3 Door Control Relay 5 4
B LKSW ULSW
LOK+ U/L+ E
2 1 6
W–B
(∗2)
(∗2)
(∗2)
G
G G G G
P P P P
G
8 JE1 3 JE1
G
G
P
G
G
G
P
2 ML1 5 ML1
G
G
P
2 1 2 1 2 1 2 1
LOK+ U/L+ LOK+ U/L+ LOK+ U/L+ LOK+ U/L+
M M M M
F7 I4 H4 L4
Front Door Rear Door Rear Door Lock Back Door Lock
Lock Assembly RH Lock Assembly LH Assembly RH Assembly
E1
124
AVANZA (EM19Y0E)
(BAT) (IG) (BAT)
15A 7. 5A 10A
(D/L) IG1/BACK HAZARD
B
(∗2)
2 2 2
L
(∗2) 2 2 2
(∗1)
B
B–W
(∗1)
Un–Lock Warning
2
Switch Assembly
4 W
E57
Connector
Junction
1 (∗1)
E42
(∗1)
G
9
Connector
Junction
E64
2
W–R
P–B
(∗1)
(∗1)
(∗1)
(∗1)
(∗1)
(∗1)
W
G
R
P
2 1 25 12 23 4
LKM ULM B IG KYSW CTY
(∗1)
(∗1)
(∗2)
(∗2)
E62
G
P
B
L
W–B
(∗1)
P
L
(∗1)
B
(∗1)
G
P
B
L
4 5 1 3
U/L+ LOK+ U/L+ LOK+
Knob
Switch
Lock Assembly LH
M
Unlock
Lock
Front Door
E
G7
2
W–B
13 GE2
W–B
W–B
(∗1)
7
E39
Junction
Connector
E4 E1
125
AVANZA (EM19Y0E)
126
W
(∗1)
3
4
W–B W–L W–L
L1
6 ML1
(∗1) (∗1) (∗1)
L4
Back Door
Lock Assembly
1
W–L W–L
4 MJ1
(∗1) (∗1)
J1
Front Courtesy
Light Switch RH
(∗1)
W–L
Door Lock Control (LHD)
1
W–L
(∗1)
J6
Front Courtesy
Light Switch LH
(∗1)
W–L
∗ 1 : w/ Wireless Door Lock Control
1
W–L
(∗1)
J3
Rear Courtesy
Light Switch RH
(∗1)
W–L
1
1
21
18 JE2
L
(∗1) (∗1) (∗1) (∗1)
AVANZA (EM19Y0E)
CTY
J8
Rear Courtesy
Light Switch LH
E34
Combination Meter Assembly
: Parts Location
Code See Page Code See Page Code See Page
E24 26 (LHD) E64 27 (LHD) J3 29 (LHD)
E34 26 (LHD) F7 28 (LHD) J6 29 (LHD)
E39 26 (LHD) G7 28 (LHD) J8 29 (LHD)
E42 27 (LHD) H4 28 (LHD) L4 29 (LHD)
E57 27 (LHD) I4 28 (LHD)
E62 27 (LHD) J1 29 (LHD)
: Relay Blocks
Code See Page Relay Blocks (Relay Block Location)
2 23 Fuse Block Assembly (Lower Finish Panel)
: Ground Points
Code See Page Ground Points Location
E1
37 (LHD) Instrument Panel Reinforcement
E4
L1 38 (LHD) Back Door Panel
127
AVANZA (EM19Y0E)
Door Lock Control (RHD)
(BAT)
∗ 1 : w/ Wireless Door Lock Control
∗ 2 : w/o Wireless Door Lock Control
15A
(D/L)
V
(∗2)
2
L
2 (∗2)
(∗2)
(∗2)
V
L
(∗2)
R
E24
3 Door Control Relay 5 4
B LKSW ULSW
LOK+ U/L+ E
2 1 6
W–B
(∗2)
(∗2)
(∗2)
G
G G G G
P P P P
G
8 JE1 3 JE1
G
G
P
G
G
G
P
2 ML1 5 ML1
G
G
P
2 1 2 1 2 1 2 1
LOK+ U/L+ LOK+ U/L+ LOK+ U/L+ LOK+ U/L+
M M M M
G5 I4 H4 L4
Front Door Rear Door Rear Door Lock Back Door
Lock Assembly LH Lock Assembly LH Assembly RH Lock Assembly
E1
128
AVANZA (EM19Y0E)
(BAT) (IG) (BAT)
15A 7. 5A 10A
(D/L) IG1/BACK HAZARD
V
(∗2)
2 2 2
L
(∗2) 2 2 2
(∗1)
B
B–W
(∗1)
Un–Lock Warning
2
Switch Assembly
W
4
E57
Connector
(∗1)
Junction
1
E42
(∗1)
G
9
Connector
Junction
E64
2
W–R
P–B
(∗1)
(∗1)
(∗1)
(∗1)
(∗1)
(∗1)
W
G
R
P
2 1 25 12 23 4
LKM ULM B IG KYSW CTY
(∗1)
(∗1)
(∗2)
(∗2)
E62
G
P
V
L
W–B
(∗1)
(∗1)
V
L
(∗1)
G
P
V
L
4 5 2 6
U/L+ LOK+ U/L+ LOK+
Knob
M Switch
Unlock
Lock
E
F5
1
W–B
13 FE1
W–B
W–B
(∗1)
7
E39
Junction
Connector
E4 E1
129
AVANZA (EM19Y0E)
130
W
(∗1)
3
4
W–B W–L W–L
L1
6 ML1
(∗1) (∗1) (∗1)
L4
Back Door
Lock Assembly
1
W–L W–L
Door Lock Control (RHD)
4 MJ1
(∗1) (∗1)
J1
Front Courtesy
Light Switch RH
(∗1)
W–L
1
W–L
∗ 1 : w/ Wireless Door Lock Control
(∗1)
J6
Front Courtesy
Light Switch LH
(∗1)
W–L
1
W–L
(∗1)
J3
Rear Courtesy
Light Switch RH
AVANZA (EM19Y0E)
(∗1)
W–L
1
1
21
18 JE2
L
J8
Rear Courtesy
Light Switch LH
E34
Combination Meter Assembly
: Parts Location
Code See Page Code See Page Code See Page
E24 32 (RHD) E64 33 (RHD) J3 35 (RHD)
E34 32 (RHD) F5 34 (RHD) J6 35 (RHD)
E39 32 (RHD) G5 34 (RHD) J8 35 (RHD)
E42 33 (RHD) H4 34 (RHD) L4 35 (RHD)
E57 33 (RHD) I4 34 (RHD)
E62 33 (RHD) J1 35 (RHD)
: Relay Blocks
Code See Page Relay Blocks (Relay Block Location)
2 23 Fuse Block Assembly (Lower Finish Panel)
: Ground Points
Code See Page Ground Points Location
E1
41 (RHD) Instrument Panel Reinforcement
E4
L1 42 (RHD) Back Door Panel
131
AVANZA (EM19Y0E)
Wireless Door Lock Control (LHD)
G G G
P P P
G
8 JE1 3 JE1
G
G
P
G
G
G
P
2 ML1 5 ML1
G
G
P
2 1 2 1 2 1 2 1
LOK+ U/L+ LOK+ U/L+ LOK+ U/L+ LOK+ U/L+
M M M M
F7 I4 H4 L4
Front Door Rear Door Rear Door Lock Back Door Lock
Lock Assembly RH Lock Assembly LH Assembly RH Assembly
132
AVANZA (EM19Y0E)
(BAT) (IG) (BAT)
15A 7. 5A 10A
(D/L) IG1/BACK HAZARD
2 2 2
2 2 2
B–W
Un–Lock Warning
2
Switch Assembly
4 W
E57
Connector
Junction
1
E42
G
9
Connector
Junction
E64
2
W–R
P–B
W
G
R
P
2 1 25 12 23 4
G
P
G E62
Door Control Receiver
CHR E RMLP
P
17 15 14
W–B
W–L
G
R
P
5
Connector
17 GE2 8 GE2
Junction
E64
G
P
4 5
B–Y
U/L+ LOK+
M
8
EHW
G7
Front Door E35
Lock Assembly LH Turn Signal
Flasher Assembly
W–B
W–L
E1
133
AVANZA (EM19Y0E)
134
W
W–L
3
4
W–B W–L W–L
L1
6 ML1
L4
Back Door
Lock Assembly
1
W–L W–L
4 MJ1
J1
Front Courtesy
Light Switch RH
Wireless Door Lock Control (LHD)
W–L
1
W–L
J6
Front Courtesy
Light Switch LH
W–L
1
W–L
AVANZA (EM19Y0E)
J3
Rear Courtesy
Light Switch RH
W–L
1
1
21
18 JE2
L
CTY
J8
Rear Courtesy
Light Switch LH
E34
Combination Meter Assembly
W–L
W–L
K4
Map Light Assembly
7
6
W–B L
–
+
(∗1) (∗1)
1
W–L
DR
(∗1)
2
W–L W–L B
DOOR
9 KE1
(∗2) R
DR
1
OFF
+
(∗2)
ON
–
K1
BR W–B W–B Map Light Assembly
E3
4 KE1
(∗2)
W–B
1
W–L
DOOR
2
5
2
12
LG LG LG P P
1
DR
8
10 KE1
2 AE4
OFF
+
(BAT)
E4
ON
E48
K2 Junction
10A
E39
No. 1 Room Light Assembly Connector
STOP
AVANZA (EM19Y0E)
Junction
Connector
∗ 1 : w/ Glasses Case
∗ 2 : w/o Glasses Case
135
Wireless Door Lock Control (LHD)
: Parts Location
Code See Page Code See Page Code See Page
E34 26 (LHD) E64 27 (LHD) J6 29 (LHD)
E35 26 (LHD) F7 28 (LHD) J8 29 (LHD)
E39 26 (LHD) G7 28 (LHD) K1 29 (LHD)
E42 27 (LHD) H4 28 (LHD) K2 29 (LHD)
E48 27 (LHD) I4 28 (LHD) K4 29 (LHD)
E57 27 (LHD) J1 29 (LHD) L4 29 (LHD)
E62 27 (LHD) J3 29 (LHD)
: Relay Blocks
Code See Page Relay Blocks (Relay Block Location)
1 22 Engine Room R/B Assembly (Engine Compartment Right)
2 23 Fuse Block Assembly (Lower Finish Panel)
: Ground Points
Code See Page Ground Points Location
E1
E3 37 (LHD) Instrument Panel Reinforcement
E4
L1 38 (LHD) Back Door Panel
136
AVANZA (EM19Y0E)
Memo
137
AVANZA (EM19Y0E)
Wireless Door Lock Control (RHD)
G G G
P P P
G
8 JE1 3 JE1
G
G
P
G
G
G
P
2 ML1 5 ML1
G
G
P
2 1 2 1 2 1 2 1
LOK+ U/L+ LOK+ U/L+ LOK+ U/L+ LOK+ U/L+
M M M M
G5 I4 H4 L4
Front Door Rear Door Rear Door Lock Back Door
Lock Assembly LH Lock Assembly LH Assembly RH Lock Assembly
138
AVANZA (EM19Y0E)
(BAT) (IG) (BAT)
15A 7. 5A 10A
(D/L) IG1/BACK HAZARD
2 2 2
2 2 2
B–W
Un–Lock Warning
2
Switch Assembly
4 W
E57
Connector
Junction
1
E42
G
9
Connector
Junction
E64
2
W–R
P–B
W
G
R
P
G
P
2 1 25 12 23 4
LKM ULM B IG KYSW CTY
G E62
Door Control Receiver
CHR E RMLP
P
17 15 14
W–B
W–L
G
R
P
5
Connector
17 FE1 8 FE1
Junction
E64
G
P
4 5
B–Y
U/L+ LOK+
M
8
EHW
F5
Front Door Lock Assembly RH E35
Turn Signal
Flasher Assembly
W–B
W–L
E1
139
AVANZA (EM19Y0E)
140
W
W–L
3
4
W–B W–L W–L
L1
6 ML1
L4
Back Door
Lock Assembly
1
W–L W–L
4 MJ1
J1
Front Courtesy
Light Switch RH
W–L
Wireless Door Lock Control (RHD)
1
W–L
J6
Front Courtesy
Light Switch LH
W–L
1
W–L
AVANZA (EM19Y0E)
J3
Rear Courtesy
Light Switch RH
W–L
1
1
21
18 JE2
L
CTY
J8
Rear Courtesy
Light Switch LH
E34
Combination Meter Assembly
W–L
(BAT)
10A
STOP
∗ 1 : w/ Glasses Case
P
∗ 2 : w/o Glasses Case
∗ 3 : Except Malaysia
2 AE4
P
5
Connector
Junction
E48
12
LG
10 KE1
LG
(∗1)
(∗2)
(∗3)
LG
R
L
3 2
No. 1 Room Light Assembly
+ +
Map Light Assembly
6
+
DOOR
DOOR
OFF
OFF
ON
ON
– DR DR – DR
K4
K1
K2
7 1 2 1 1
W–B
W–B
W–L
W–L
(∗1)
(∗1)
(∗2)
(∗2)
(∗3)
B
W–L
9 KE1 4 KE1
W–B
W–L
W–B
8
W–L E39
BR
Junction
Connector
E3 E4
141
AVANZA (EM19Y0E)
Wireless Door Lock Control (RHD)
: Parts Location
Code See Page Code See Page Code See Page
E34 32 (RHD) E64 33 (RHD) J6 35 (RHD)
E35 32 (RHD) F5 34 (RHD) J8 35 (RHD)
E39 32 (RHD) G5 34 (RHD) K1 35 (RHD)
E42 33 (RHD) H4 34 (RHD) K2 35 (RHD)
E48 33 (RHD) I4 34 (RHD) K4 35 (RHD)
E57 33 (RHD) J1 35 (RHD) L4 35 (RHD)
E62 33 (RHD) J3 35 (RHD)
: Relay Blocks
Code See Page Relay Blocks (Relay Block Location)
1 22 Engine Room R/B Assembly (Engine Compartment Right)
2 23 Fuse Block Assembly (Lower Finish Panel)
: Ground Points
Code See Page Ground Points Location
E1
E3 41 (RHD) Instrument Panel Reinforcement
E4
L1 42 (RHD) Back Door Panel
142
AVANZA (EM19Y0E)
Memo
143
AVANZA (EM19Y0E)
Theft Deterrent
15A 7. 5A 10A
(D/L) IG1/BACK HAZARD
2 2 2
2 2 2
B–W
Un–Lock Warning
2
Switch Assembly
4
E57
Connector
Junction
1
E42
G
9
Connector
Junction
E64
2
W–R
P–B
R
25 12 23
B IG KYSW
E62
Door Control Receiver
UKS LKS E FSW CHR
6 18 15 19 17
W–B
L–R
R
(RHD)
(RHD)
(LHD)
(LHD)
V
B
L
Connector
Junction
(RHD)
(RHD)
(LHD)
(LHD)
L–R
V
B
L
E64
Engine Hood Switch
6
Front Door Lock Assembly RH
2 6 1 3 2
U/L+ LOK+ U/L+ LOK+
B–Y
Knob Knob
Switch Switch
Lock Assembly LH
B15
Unlock
Unlock
Lock
Lock
1
Front Door
8
EHW
E E
G7
F5
1 2
W–B
E35
(RHD)
(LHD)
Turn Signal
W–B
W–B
Flasher Assembly
10 BE3
13 FE1 13 GE2
(RHD)
(LHD)
W–B
W–B
W–B
W–B
7 W–B
E39
Junction
Connector
E4 E1 E2
144
AVANZA (EM19Y0E)
(BAT)
10A
HORN
LG
B
1 1
2 3
HORN
Relay
1 5
1 1
E62
R–W
Door Control Receiver
L
R–G
R–W
R–W
3
Connector
11 BE3
Junction
L
E64
R–W
High Pitched Horn Assembly
10
1 1
A1
B9
R–G
W–L
145
AVANZA (EM19Y0E)
146
W
R–G
W–L
Theft Deterrent
Security
5
16
34
BR
E4
E
B
E39
1
21
Junction
Connector
CTY
E34
Combination Meter
Assembly
3
4
W–B W–L W–L
L1
6 ML1
L4
Back Door
Lock Assembly
1
W–L W–L
4 MJ1
J1
Front Courtesy
Light Switch RH
W–L
AVANZA (EM19Y0E)
1
W–L
J6
Front Courtesy
Light Switch LH
W–L
1
W–L
J3
Rear Courtesy
Light Switch RH
W–L
1
W–L W–L W–L
18 JE2
J8
Rear Courtesy
Light Switch LH
W–L
(BAT)
10A
STOP
∗ 1 : w/ Glasses Case
P
∗ 2 : w/o Glasses Case
∗ 3 : Except Malaysia
2 AE4
P
5
Connector
Junction
E48
12
LG
10 KE1
LG
(∗1)
(∗2)
(∗3)
LG
R
L
3 2
No. 1 Room Light Assembly
+ +
Map Light Assembly
6
+
DOOR
DOOR
OFF
OFF
ON
ON
– DR DR – DR
K4
K1
K2
7 1 2 1 1
W–B
W–B
W–L
W–L
(∗1)
(∗1)
(∗2)
(∗2)
(∗3)
B
W–L
9 KE1 4 KE1
W–B
W–L
W–L
W–B
8
E39
BR
Junction
Connector
E3 E4
147
AVANZA (EM19Y0E)
Theft Deterrent
: Parts Location
Code See Page Code See Page Code See Page
24 (LHD) 27 (LHD) 29 (LHD)
A1 E48 J6
30 (RHD) 33 (RHD) 35 (RHD)
24 (LHD) 27 (LHD) 29 (LHD)
B9 E57 J8
30 (RHD) 33 (RHD) 35 (RHD)
24 (LHD) 27 (LHD) 29 (LHD)
B15 E62 K1
30 (RHD) 33 (RHD) 35 (RHD)
26 (LHD) 27 (LHD) 29 (LHD)
E34 E64 K2
32 (RHD) 33 (RHD) 35 (RHD)
26 (LHD) F5 34 (RHD) 29 (LHD)
E35 K4
32 (RHD) G7 28 (LHD) 35 (RHD)
26 (LHD) 29 (LHD) 29 (LHD)
E39 J1 L4
32 (RHD) 35 (RHD) 35 (RHD)
27 (LHD) 29 (LHD)
E42 J3
33 (RHD) 35 (RHD)
: Relay Blocks
Code See Page Relay Blocks (Relay Block Location)
1 22 Engine Room R/B Assembly (Engine Compartment Right)
2 23 Fuse Block Assembly (Lower Finish Panel)
: Ground Points
Code See Page Ground Points Location
37 (LHD)
E1
41 (RHD)
37 (LHD)
E2
41 (RHD)
Instrument Panel Reinforcement
37 (LHD)
E3
41 (RHD)
37 (LHD)
E4
41 (RHD)
38 (LHD)
L1 Back Door Panel
42 (RHD)
148
AVANZA (EM19Y0E)
Memo
149
AVANZA (EM19Y0E)
Power Window (LHD)
(IG) G6
1 Power Window Regulator Master Switch Assembly
IG
30A
POWER
2
Window Lock Switch
W–G
18 GE2
W–G
E M/U+ M/D+
6 10 11
W–G
W–G
W–B
R
P
10 GE2
W–G
W–G
9 FE2
W–B
W–G
W–G
R
P
1 2
U+ D+
G3
Front Power Window Regulator
Motor Assembly LH
E3
150
AVANZA (EM19Y0E)
G6
Power Window Regulator Master Switch Assembly
Control Switch LH
Down
Down
Down
Up
Up
Up
PU+ PD+ RLU+ RLD+ RRU+ RRD+
2 5 7 3 12 4
W–R
B–W
W–L
LG
W
G
W–G
W–L
LG
W–G
W–G
W–R
B–W
W
G
W–G
B–W
W–L
LG
LG
W
G
3 IJ1 3 HJ1
1 5 1 5 1 5
W–G
W–G
U+ D+ U+ D+ U+ D+
Switch Assembly RH
Switch Assembly RH
Switch Assembly LH
W–G 3 B 3 B 3 B
Down
Down
Down
Up
Up
Up
I3
2 4 2 4 2 4
R–Y
R–Y
L–R
G
P
1 2 1 2 1 2
U+ D+ U+ D+ U+ D+
M M M
F3 I2 H2
Front Power Window Regulator Rear Power Window Regulator Rear Power Window Regulator
Motor Assembly RH Motor Assembly LH Motor Assembly RH
151
AVANZA (EM19Y0E)
Power Window (LHD)
: Parts Location
Code See Page Code See Page Code See Page
F3 28 (LHD) G6 28 (LHD) I2 28 (LHD)
F6 28 (LHD) H2 28 (LHD) I3 28 (LHD)
G3 28 (LHD) H3 28 (LHD)
: Relay Blocks
Code See Page Relay Blocks (Relay Block Location)
2 23 Fuse Block Assembly (Lower Finish Panel)
: Ground Points
Code See Page Ground Points Location
E3 37 (LHD) Instrument Panel Reinforcement
152
AVANZA (EM19Y0E)
Memo
153
AVANZA (EM19Y0E)
Power Window (RHD)
(IG) F4
1 Power Window Regulator Master Switch Assembly
IG
30A
POWER
2
Window Lock Switch
W–G
18 FE1
W–G
E M/U+ M/D+
6 10 11
W–G
W–G
W–B
R
P
10 FE1
W–G
W–G
9 GE1
W–B
W–G
W–G
R
P
1 2
U+ D+
F3
Front Power Window
Regulator Motor Assembly RH
E3
154
AVANZA (EM19Y0E)
F4
Power Window Regulator Master Switch Assembly
Down
Down
Up
Up
Up
PU+ PD+ RLU+ RLD+ RRU+ RRD+
7 12 5 4 2 3
W–R
B–W
W–L
LG
W
G
W–G
W–L
LG
W–G
W–G
W–R
B–W
W
G
W–G
B–W
W–L
LG
LG
W
G
3 IJ1 3 HJ1
1 5 1 5 1 5
W–G
W–G
U+ D+ U+ D+ U+ D+
Switch Assembly RH
Switch Assembly LH
Switch Assembly LH
W–G 3 B 3 B 3 B
Down
Down
Down
Up
Up
Up
H3
I3
2 4 2 4 2 4
R–Y
R–Y
L–R
G
P
1 2 1 2 1 2
U+ D+ U+ D+ U+ D+
M M M
G3 I2 H2
Front Power Window Regulator Rear Power Window Regulator Rear Power Window Regulator
Motor Assembly LH Motor Assembly LH Motor Assembly RH
155
AVANZA (EM19Y0E)
Power Window (RHD)
: Parts Location
Code See Page Code See Page Code See Page
F3 34 (RHD) G4 34 (RHD) I2 34 (RHD)
F4 34 (RHD) H2 34 (RHD) I3 34 (RHD)
G3 34 (RHD) H3 34 (RHD)
: Relay Blocks
Code See Page Relay Blocks (Relay Block Location)
2 23 Fuse Block Assembly (Lower Finish Panel)
: Ground Points
Code See Page Ground Points Location
E3 41 (RHD) Instrument Panel Reinforcement
156
AVANZA (EM19Y0E)
Memo
157
AVANZA (EM19Y0E)
Front Wiper and Washer
(IG)
G
2 WB +2 +1 +S INT1 INT2 B1
MIST
2
5 BE6 (LHD)
OFF Front Washer Switch 8 BE2 (RHD)
INT EW W
G
LO Off
HI On
B6
1
L
Wiper Relay
4 BE6 (LHD)
WB 2 1 +S EW W 7 BE2 (RHD)
8 A 9 A 7 A 6 A 5 A 4 A (LHD)
3 B 2 B 4 B 5 B 6 B 7 B (RHD)
W–R
W–B
W–L
G
L
W–R
G
W–L
G
4 A 3 A 1 A 2 A (LHD)
4 B 3 B 1 B 2 B (RHD)
+B S HI LO
W–B
8
E39
Junction
A10(A), B8(B) Connector
Windshield Wiper
Motor Assembly
E4
158
AVANZA (EM19Y0E)
: Parts Location
Code See Page Code See Page Code See Page
A10 A 24 (LHD) B8 B 30 (RHD) 26 (LHD)
E39
24 (LHD) A 26 (LHD) 32 (RHD)
B6 E30
30 (RHD) B 32 (RHD)
: Relay Blocks
Code See Page Relay Blocks (Relay Block Location)
2 23 Fuse Block Assembly (Lower Finish Panel)
: Ground Points
Code See Page Ground Points Location
37 (LHD)
E4 Instrument Panel Reinforcement
41 (RHD)
159
AVANZA (EM19Y0E)
Rear Wiper and Washer
(IG)
15A
(RR WIP)
W
W
6 BE6 (LHD)
6 JE1 10 BE2 (RHD)
R–W
R–W
W
W
2
9 MJ1 8 MJ1 7 JE1
B7
M Rear Washer
Motor Assembly
1
R–W
W
V
7 ML1 8 ML1 2 BE6 (LHD)
9 BE2 (RHD)
R–W
R–W
W
2 A 3 A (LHD)
2 1 9 B 8 B (RHD)
+ – +1R WR
+1R WR EW
M
Rear Wiper and
Washer
Washer Switch
OFF
ON
L1
Rear Wiper On+
Motor Assembly Washer
EW
E30(A), (B) 5 A (LHD)
Windshield Wiper 6 B (RHD)
Switch Assembly
W–B
8
E39
Junction
Connector
E4
160
AVANZA (EM19Y0E)
: Parts Location
Code See Page Code See Page Code See Page
24 (LHD) E30 B 32 (RHD) 29 (LHD)
B7 L1
30 (RHD) 26 (LHD) 35 (RHD)
E39
E30 A 26 (LHD) 32 (RHD)
: Relay Blocks
Code See Page Relay Blocks (Relay Block Location)
2 23 Fuse Block Assembly (Lower Finish Panel)
: Ground Points
Code See Page Ground Points Location
37 (LHD)
E4 Instrument Panel Reinforcement
41 (RHD)
161
AVANZA (EM19Y0E)
Horn
(BAT)
10A
HORN
LG
3 : w/ Steering Pad Switch
B
∗ 4 : w/ SRS
∗ 5 : w/o SRS
∗ 6 : w/ Theft Deterrent
∗ 7 : w/o Theft Deterrent
1 1
2 3
10
Connector
HORN
Junction
Relay
E64
11 1 5
1 1
R–W
R–W
(∗6)
L
13 AE4 11 AE4
R–W
(∗2 ∗4 ∗6)
(∗2 ∗4 ∗7)
(∗3 ∗4 ∗6)
(∗3 ∗4 ∗7)
(∗5)
LG
LG
LG
LG
LG
11 BE3
Sub–Assembly
Sub–Assembly
E54(A), z4(B)
E32(A), z3(B)
Spiral Cable
Spiral Cable
1 A 1 A
R–W
R–W
High Pitched Horn Assembly
+ +
1 B 1 B 1
1 1
Switch
Switch
Horn
Horn
E31
A1
B9
z4(B) z3(B)
Horn Button Assembly Steering Wheel
Sub–Assembly
162
AVANZA (EM19Y0E)
: Parts Location
Code See Page Code See Page Code See Page
24 (LHD) 26 (LHD) 27 (LHD)
A1 E32 A z3 B
30 (RHD) 32 (RHD) 33 (RHD)
24 (LHD) 27 (LHD) 27 (LHD)
B9 E54 A z4 B
30 (RHD) 33 (RHD) 33 (RHD)
26 (LHD) 27 (LHD)
E31 E64
32 (RHD) 33 (RHD)
: Relay Blocks
Code See Page Relay Blocks (Relay Block Location)
1 22 Engine Room R/B Assembly (Engine Compartment Right)
163
AVANZA (EM19Y0E)
164
8
1
2
2
E4
(ACC)
Cigarette Lighter or Power Outlet
E39
Junction Connector E15
15A
(CIG)
AVANZA (EM19Y0E)
: Parts Location
Code See Page Code See Page Code See Page
26 (LHD) 26 (LHD)
E15 E39
32 (RHD) 32 (RHD)
: Relay Blocks
Code See Page Relay Blocks (Relay Block Location)
2 23 Fuse Block Assembly (Lower Finish Panel)
: Ground Points
Code See Page Ground Points Location
37 (LHD)
E4 Instrument Panel Reinforcement
41 (RHD)
165
AVANZA (EM19Y0E)
Rear Window Defogger
(IG)
20A
(DEF)
L–B
E7
Rear Window Defogger
3 Switch Assembly
B
L E
4 5
P
11
Connector
W–B
Junction
E43
10
B
4 JE1
B
12
Connector
Junction
E43
6 MJ1 14
B
4 ML1
B
1 NL1
B
1 A
N1(A), O1(B)
BR
1 B
B
6
Connector
Junction
E39
O1 E4
166
AVANZA (EM19Y0E)
: Parts Location
Code See Page Code See Page Code See Page
26 (LHD) 27 (LHD) 29 (LHD)
E7 E43 O1 B
32 (RHD) 33 (RHD) 35 (RHD)
26 (LHD) 29 (LHD)
E39 N1 A
32 (RHD) 35 (RHD)
: Relay Blocks
Code See Page Relay Blocks (Relay Block Location)
2 23 Fuse Block Assembly (Lower Finish Panel)
: Ground Points
Code See Page Ground Points Location
37 (LHD)
E4 Instrument Panel Reinforcement
41 (RHD)
38 (LHD)
O1 Back Door Panel
42 (RHD)
167
AVANZA (EM19Y0E)
Audio System
(BAT) (ACC)
10A 10A
BACK UP ACC
2 2
1 2
B–W
(A/T)
L
2
Connector
Junction
(M/T)
8 AE4
L
E48
9
W–G
(A/T)
B–W
B–W
(∗2)
(∗2)
(∗2)
(∗2)
W
R
2 4 6 13
Connector
Connector
Junction
Junction
(∗1, ∗3)
(∗1, ∗3)
(∗1, ∗3)
(∗1, ∗3)
R–W
B–W
W
R
E44
E44
1 8 3 10 5 12 7 14
(∗2)
(∗2)
(∗2)
(∗2)
LG
W
R
V
(RHD)
(LHD)
(LHD)
R–W
R–W
R–W
B–W
B–W
B–W
(∗2)
(∗2)
(∗2)
(∗2)
W
G
R
L
2 1 2 1 2 1 2 1
E2 G1 E37 F1
No. 1 with Box Speaker Front No. 3 Speaker No. 1 with Box Speaker Front No. 3 Speaker
Assembly LH Assembly LH Assembly RH Assembly RH
168
AVANZA (EM19Y0E)
∗ 1 : 4 Speaker
∗ 2 : 6 Speaker
∗ 3 : 2 Speaker
∗ 4 : w/ Steering Pad Switch
∗ 5 : w/ No. 1 Stereo Jack Adapter
Sub–Assembly
E32(A), z3(B)
Spiral Cable
5 B 3 B 4 B
R–W
B–Y
(∗4)
(∗4)
(∗4)
SRL+ SRL– SRR+ SRR– E ALI ARI ASGN AUXG UPO UDI– UDI+ UESG
2 C 6 C 1 C 3 C 7 A 17 B 15 B 18 B 16 B 1 D 2 D 3 D 4 D
W–B
(Shielded)
(∗1, ∗2)
(∗1, ∗2)
(∗1, ∗2)
(∗1, ∗2)
R–W
B–W
(∗5)
(∗5)
(∗5)
(∗5)
LG
W
R
V
(∗5)
(∗5)
(∗5)
#
#
(∗1, ∗2)
(∗1, ∗2)
(∗1, ∗2)
(∗1, ∗2)
R–W
B–W
LG
(Shielded)
(∗5)
(∗5)
(∗5)
(∗5)
W
R
6 5 7 9 1 2 3 4
ALO ARO ASGN AGND UPI UDO– UDO+ UJSG
E52
No. 1 Stereo Jack Adapter Assembly
(∗1, ∗2)
(∗1, ∗2)
(∗1, ∗2)
(∗1, ∗2)
R–W
R–W
B–W
B–W
2 1 2 1
I1 H1
Rear Stereo Rear Stereo
Component Speaker Component Speaker
Assembly LH Assembly RH
W–B
E1
169
AVANZA (EM19Y0E)
Audio System
: Parts Location
Code See Page Code See Page Code See Page
26 (LHD) 26 (LHD) 28 (LHD)
E2 E37 F1
32 (RHD) 32 (RHD) 34 (RHD)
26 (LHD) 27 (LHD) 28 (LHD)
E4 A E44 G1
32 (RHD) 33 (RHD) 34 (RHD)
26 (LHD) 27 (LHD) 28 (LHD)
E5 B E48 H1
32 (RHD) 33 (RHD) 34 (RHD)
26 (LHD) 27 (LHD) 28 (LHD)
E6 C E52 I1
32 (RHD) 33 (RHD) 34 (RHD)
26 (LHD) 27 (LHD) 27 (LHD)
E32 A E53 D z3 B
32 (RHD) 33 (RHD) 33 (RHD)
: Relay Blocks
Code See Page Relay Blocks (Relay Block Location)
1 22 Engine Room R/B Assembly (Engine Compartment Right)
2 23 Fuse Block Assembly (Lower Finish Panel)
: Ground Points
Code See Page Ground Points Location
37 (LHD)
E1 Instrument Panel Reinforcement
41 (RHD)
170
AVANZA (EM19Y0E)
Memo
171
AVANZA (EM19Y0E)
172
2
11
W–B
E4
GND
(M/T ∗3)
E39
1
3
W–G
Junction
IG
Connector
OUT
(M/T ∗3)
E50
Speedometer Sensor
E34
Combination Meter Assembly
Front Courtesy Light Switch RH
1
W–L Front Courtesy Light Switch LH
Rear Courtesy Light Switch RH
Combination Meter
L–W
Rear Courtesy Light Switch LH
(M/T ∗3)
Back Door Lock Assembly
21
W Map Light Assembly
Door
(∗8) No. 1 Room Light Assembly
CTY
(∗5) (∗5)
W
Door Control Receiver
(∗6) (∗6) (∗7)
12
L–W
(A/T ∗2)
2
40
B–W B–W
SPDI
1
8 AE4
(BAT)
+B
R–W R–W
(∗2)
17 BE4
(M/T ∗1) (M/T ∗1)
10A
W–G
E62
BACK UP
(M/T ∗3)
21
13
B–Y LG–R
8 A
3 B
Receiver
8
SPD
(∗9) (∗4)
AVANZA (EM19Y0E)
9
2
2
39
Door Control
R–L LG
2
SPSR
Speedometer
(IG)
(M/T) (M/T)
IG
E48
LG–B Junction
9 A
4 B
10A
E40(A), E41(B)
LG
R–L
(A/T)
(A/T)
Junction
Connector
W–L
Tachometer
9
2
E27(B)
E43
5 B
SPD
Junction
Connector
ECU Assembly
Power Steering
LCD
G–R
DLC3
T
R–W
(∗4)
(M/T ∗1)
L–W(A/T ∗2)
LG–B(M/T ∗2)
∗ 1 : w/ ABS
∗ 2 : w/o Multi Information Display
∗ 3 : w/o ABS
∗ 4 : w/ Multi Information Display
∗ 5 : w/ Door Indicator Light
∗ 6 : w/o Door Indicator Light
∗ 7 : w/ Wireless Door Lock Control
∗ 8 : w/o Wireless Door Lock Control
∗ 9 : Malaysia
Park/Neutral Position
Switch Assembly
LG–B
W–G
R–Y
P–B
B–Y
B–L
(∗2)
(∗2)
(∗2)
(∗2)
(∗2)
(∗2)
(∗2)
G
E34
7 22 23 26 27 24 25 Combination Meter Assembly
R+ P N 2 L D 3
CPU
–
8
B(RHD ∗1)
B B
(RHD ∗3)
7 BE3
1 BE4
(LHD)
12 AE3
B–W
B
B–R
(∗1)
LG
W
R
V
B
L
1
Sub–Assembly)
Warning Switch
(RHD)
19 18 7 6 5 4 17 16 23
(Brake Master Cylinder
B
+
Reservoir
1
(LHD)
W–B
Warning Switch
–
B13
+
VWOT PKB
2
22 B10 30 10 BE3
Brake Actuator Assembly –
A7
2
R–W LG–R
(M/T ∗1) (∗1)
(RHD)
(LHD)
W–B
W–B
A1 E1
173
AVANZA (EM19Y0E)
174
B
(∗1)
LG–R
(LHD ∗1)
B(RHD ∗1)
L–W(A/T ∗2)
LG–B(M/T ∗2)
Front Seat Inner
35
L–R Belt Assembly RH
LG–R LG–R Front Seat Inner
1 A
10 B
Belt Assembly LH
2 BE4
(∗1) (∗1)
DBLT
2 A
E40(A), E41(B)
(∗1)
W–R
Junction
Connector
Combination Meter
1
9
35
W–R W–R L–B Un–Lock Warning
14 JE2
(∗3) Switch Assembly
PKB
KEY
J5
Parking Brake Switch
19
L–Y L–Y L–Y
2 PJ1
9 JE2
+
Gauge
3
2
BR BR
J2
1 PJ1
–
+
CPU
P1
Fuel with Motor &
Bracket Pump Assembly
AVANZA (EM19Y0E)
E34
G(M/T ∗4)
29
W(A/T ∗4)
B(A/T ∗4)
CANL
CAN IC
28
R(M/T ∗4)
Combination Meter Assembly
CANH
Clock
5
16
BR
E4
E
E39
ODO/TRIP
(∗2)
Junction
ODO/TRIP
Connector
DISP(∗4)
B(A/T ∗4)
R(M/T ∗4)
G(M/T ∗4)
W(A/T ∗4)
L–W(A/T ∗2)
LG–B(M/T ∗2)
V–R
DLC3
∗ 1 : w/ ABS
∗ 2 : w/o Multi Information Display
∗ 3 : w/o ABS
R–W
V–R
∗ 4 : w/ Multi Information Display
Power Steering
ECU Assembly
5 A 7 A
E40(A), E41(B)
Connector
Junction
6 B 5 B
R–B
B–Y
E34
10 Combination Meter Assembly
REV
Buzzer
Seat Belt
Driver' s
Brake
ABS
AT
CPU
(∗4)
(∗2)
(∗4)
(∗4)
(∗4)
+ – WNG
20 18 31
G–B
V–R
(∗2)
L
Transmission
Assembly
Control ECU
Actuator
Assembly
Brake
5 CE1
L
175
AVANZA (EM19Y0E)
176
V–R
L
B(A/T ∗4)
R(M/T ∗4)
G(M/T ∗4)
W(A/T ∗4)
L–W(A/T ∗2)
LG–B(M/T ∗2)
Temperature Hot
Security
34
R–G Door Control
Combination Meter
B
Receiver
Charge
36
R–W
E34
Generator
Assembly
CHG
17
Airbag ECU V
Assembly
A/B
SRS
Combination Meter Assembly
High Beam
2
P Headlight Dimmer
+
Switch Assembly
AVANZA (EM19Y0E)
Turn LH
5
L–W
+
Turn Signal
Flasher Assembly
Turn RH
3
G–W
+
Power Steering
15
Power B–R
Steering
ECU Assembly EPSW
L
B(A/T ∗4)
R(M/T ∗4)
G(M/T ∗4)
W(A/T ∗4)
V–R
L–W(A/T ∗2)
LG–B(M/T ∗2)
V–R V–R
Headlight Dimmer
Switch Assembly
LG
E34
Combination Meter Assembly 14
ILM+
Check Engine
Illumination
Illumination
Oil
Pointer
LCD
– EFI
38 37
V–W
R
R
1 6 CE1
Pressure Switch
ECM
Engine Oil
Assembly
C17
L L
177
AVANZA (EM19Y0E)
Combination Meter
V–R
(M/T ∗2)
(A/T ∗4)
(A/T ∗4)
LG–B
(M/T ∗4)
(A/T ∗2)
(A/T ∗2)
G
R
G
R
E45
6 14 8 10 Junction Connector
CANH CANL
9 11 1 3
E12
DLC3
(M/T ∗4)
(A/T ∗4)
(A/T ∗4)
(A/T ∗4)
(A/T ∗4)
LG
G
P
7 A 17 A
CANH CANL
SPDO
E9(A) 11 A
Transmission
(A/T ∗2)
Control ECU
L–W
B(A/T ∗4)
W(A/T ∗4)
G(M/T ∗4)
LG–B(M/T ∗2)
L–W(A/T ∗2)
L L
178
AVANZA (EM19Y0E)
(BAT) (IG)
15A 10A
∗ 2 : w/o Multi Information Display EFI E/G
∗ 4 : w/ Multi Information Display
2 2
1 2
LG
C23(A), C24(B), E3(C)
ECM
9 AE4
LG
W
THW E2 N+ N– # 10
14 B 33 B 9 B 29 B 4 A
2 2
(Shielded)
W–R
B–W
BR
B 3 2
Engine Coolant Temperature Sensor
EFI MAIN
Relay
L
1 2
Assembly No. 1
5 1
Crank Position
3 1
Fuel Injector
Sensor
2 2
C10
C5
2 1
C15
W–B
L
9 1 CE1
C25
Junction
Connector
4
BR
L 4
Connector
Junction
E39
C1 E4
179
AVANZA (EM19Y0E)
Combination Meter
: Parts Location
Code See Page Code See Page Code See Page
A7 30 (RHD) 27 (LHD) 27 (LHD)
C25 E41 B
24 (LHD) 33 (RHD) 33 (RHD)
B10
30 (RHD) 26 (LHD) 27 (LHD)
E3 C E43
B13 24 (LHD) 32 (RHD) 33 (RHD)
25 (LHD) 26 (LHD) 27 (LHD)
C5 E9 A E45
31 (RHD) 32 (RHD) 33 (RHD)
25 (LHD) 26 (LHD) 27 (LHD)
C10 E12 E48
31 (RHD) 32 (RHD) 33 (RHD)
25 (LHD) 26 (LHD) 27 (LHD)
C15 E27 B E50
31 (RHD) 32 (RHD) 33 (RHD)
25 (LHD) 26 (LHD) 27 (LHD)
C17 E34 E62
31 (RHD) 32 (RHD) 33 (RHD)
27 (LHD) 26 (LHD) 29 (LHD)
C23 A E39 J5
33 (RHD) 32 (RHD) 35 (RHD)
27 (LHD) 27 (LHD) 29 (LHD)
C24 B E40 A P1
33 (RHD) 33 (RHD) 35 (RHD)
: Relay Blocks
Code See Page Relay Blocks (Relay Block Location)
1 22 Engine Room R/B Assembly (Engine Compartment Right)
2 23 Fuse Block Assembly (Lower Finish Panel)
: Ground Points
Code See Page Ground Points Location
A1 41 (RHD) Cowl Side Panel RH
36 (LHD)
C1 Engine Unit
40 (RHD)
E1 37 (LHD)
37 (LHD) Instrument Panel Reinforcement
E4
41 (RHD)
38 (LHD)
J2 Center Body Pillar RH
42 (RHD)
180
AVANZA (EM19Y0E)
Memo
181
AVANZA (EM19Y0E)
Cooling Fan
(BAT) (IG)
30A 10A
RAD E/G
2 2
1 2
Temperature Sensor
2
W
L
Engine Coolant
C15
16 AE4
1
W
B–W
BR
1 1
C24(B), E3(C)
3 2 14 B 33 B ECM
THW E2
RAD
Relay
FAN N+ N–
5 1
16 C 9 B 29 B
1 1
(Shielded)
R–W
R–W
W
P
B
6 AE4
1
With Motor Fan Assembly
Crank Position
R–W
Sensor
2
C10
M 2
A6
1
9
C25
Junction
Connector
4
BR
W–B
A2 C1
182
AVANZA (EM19Y0E)
: Parts Location
Code See Page Code See Page Code See Page
24 (LHD) 25 (LHD) 27 (LHD)
A6 C15 C25
30 (RHD) 31 (RHD) 33 (RHD)
25 (LHD) 27 (LHD) 26 (LHD)
C10 C24 B E3 C
31 (RHD) 33 (RHD) 32 (RHD)
: Relay Blocks
Code See Page Relay Blocks (Relay Block Location)
1 22 Engine Room R/B Assembly (Engine Compartment Right)
2 23 Fuse Block Assembly (Lower Finish Panel)
: Ground Points
Code See Page Ground Points Location
37 (LHD)
A2 Cowl Side Panel RH
41 (RHD)
36 (LHD)
C1 Engine Unit
40 (RHD)
183
AVANZA (EM19Y0E)
Air Conditioner
P
(∗1)
2 (BAT) (BAT)
2
40A 10A
HTR (A/C NO. 2)
∗ 1 : w/ Heater 7. 5A
∗ 2 : w/o Heater (HTR SUB)
∗ 3 : w/ Rear A/C 2 2
1 1 2
2 R–W
G
(∗3)
(∗1)
L
R–W
5 AE2
(∗1)
L
G
2
E16 2 2
M Blower Motor
(Cooler Unit
(∗1)
Assembly)
L
1 5 2
(∗2)
W
4 HTR
Relay
3 1
W
4
(Cooler Unit Assembly)
2 2 2
+
Blower Resistor
V
M2 M&M1 L
E17
2 3 1
W–B
W
3 Connector
Junction
R–W 10
E48
11 4
4 5 6 8
B–Y
L–R
(∗3)
H M2 M, M1 L
H M2 M, M1 L E
W–B
OFF
Blower Switch
4 B–Y
(∗3)
E
E14 L–R
1
Heater Control Assembly
W–B
4
E39
Junction
Connector
E2 E4
184
AVANZA (EM19Y0E)
K3
P
(∗3)
(∗3)
(∗1)
L–R
B–Y
R–W
Switch
Blower
Rear Cooling
Unit Assembly
L
Hi
Me
OFF
1
B–Y B–Y
3 KE1
E
(∗3) (∗3)
Blower Motor
2
R–W R–W
M
8 KE1
+
(∗3) (∗3)
1
5
3
2
1
1
1
+
10 AE4
7 CE1
(BAT)
1
2
C18 G–W V V
1
1
10A
17 AE4
With Pulley
Compressor Assembly
G–W
(A/C NO. 1)
Relay
(MGC)
3
7 AE4
V
B5
No. 1 Pressure Switch
(Cooler Refrigerant
Liquid Pipe)
2
1
4
2
10
15 C
29 C
(IG)
MGC
(∗2)
ACSW
E42
E11 Junction
3 BE6 (LHD)
1 BE6 (LHD)
6 BE2 (RHD)
5 BE2 (RHD)
Cooler Thermistor Connector
7. 5A
L–R
11 C
(Cooler Unit Assembly)
BLW
IG1/BACK
1
2
W–R R–Y
14 C
ACEV
ECM
E3(C)
E13
Heater Control Assembly
AVANZA (EM19Y0E)
A/C Volume Switch
(∗1)
1
B–Y
LG–R
30 C
+
ACVR
(∗2)
2
L–Y
–
(∗2)
E65
Cooler Switch
4
2
L–Y P
1 B
–
(∗2) (∗1)
+B
R–G R–Y
10 A
2 B
31 C
E21
E40(A), E41(B)
Junction Connector
1
3
GR
E4
–
(∗1)
E39
Junction Connector
185
Air Conditioner
: Parts Location
Code See Page Code See Page Code See Page
24 (LHD) 26 (LHD) 27 (LHD)
B5 E14 E41 B
30 (RHD) 32 (RHD) 33 (RHD)
25 (LHD) 26 (LHD) 27 (LHD)
C18 E16 E42
31 (RHD) 32 (RHD) 33 (RHD)
26 (LHD) 26 (LHD) 27 (LHD)
E3 C E17 E48
32 (RHD) 32 (RHD) 33 (RHD)
26 (LHD) 26 (LHD) 27 (LHD)
E11 E39 E65
32 (RHD) 32 (RHD) 33 (RHD)
26 (LHD) 27 (LHD) 29 (LHD)
E13 E40 A K3
32 (RHD) 33 (RHD) 35 (RHD)
: Relay Blocks
Code See Page Relay Blocks (Relay Block Location)
1 22 Engine Room R/B Assembly (Engine Compartment Right)
2 23 Fuse Block Assembly (Lower Finish Panel)
: Ground Points
Code See Page Ground Points Location
37 (LHD)
E2
41 (RHD)
Instrument Panel Reinforcement
37 (LHD)
E4
41 (RHD)
186
AVANZA (EM19Y0E)
Memo
187
AVANZA (EM19Y0E)
I GROUND POINT
W–B
A9 (–)
Side Turn Signal
Light Assembly RH
W–B W–B
A6 (–) (–) A4
With Motor Headlight
Fan Assembly Assembly RH
W–B W–B
W–B
W–B
A2 (–) (–) A5
Headlight Assembly RH Fog Light
Assembly RH
W–B
A7 (–)
Brake Fluid Level (RHD)
Warning Switch
(Brake Master Cylinder
Reservoir Sub–Assembly) A1 A2
C25
Junction
Connector
9 (Shielded)
8 (Shielded)
3 (Shielded)
2 (Shielded)
W–B 11 1 (Shielded)
C24 (E1)
ECM 8 BR
(E01) E9
4 (A/T) Transmission
Control ECU
BR
W–B 9 BR Assembly
(E01) (E02)
(A/T)
C1 1 2 BR
(E1)
(A/T)
E46
Junction Connector
(A/T)
W–B
W–B
(–) C1
Ignition Coil
Assembly No. 1
8 CE1 W–B
(–) C2
Ignition Coil
Assembly No. 2
W–B
W–B
(A/T)
W–B
(–) C3
Ignition Coil
Assembly No. 3
W–B
W–B W–B
(–) C4
Ignition Coil
Assembly No. 4
C2
188
AVANZA (EM19Y0E)
I
BR
(E) E58
Transponder
Key ECU Assembly
12 W–B
(E) E7
Rear Window
Defogger Switch
Assembly
10 5 W–B
6 (–)
W–B W–B 3
E60 (E1) EE2
Airbag ECU Assembly
13 GR
(E) E19
Shift Lock
BR 10 Control ECU
Junction Connector
E23 (E)
Park/Neutral Position (A/T)
Switch Assembly 6 BR 14 6 BR
(KSO–) E29
Key Inter
BR 4 E43 Lock Solenoid
E3 (SL) (Steering Column
E46
Connector
ECM (A/T) Junction Upper with
Junction
Connector Switch Bracket
Assembly)
E39
GR 11 3 W–B
E18 (ILL–)
Transmission Floor (A/T) (A/T) 1 GR
(–) E65
Shift Assembly Cooler Switch
BR 5 2 W–B
E34 (E) (–) E59
Combination Ash Receptacle
Meter Assembly Light
Sub–Assembly
13
W–B W–B 7 4
F5 (E) FE1
Front Door Lock (RHD) (RHD)
Assembly RH
13
W–B W–B
G7 (E) GE2
Front Door Lock (LHD) (LHD) E4
Assembly LH
W–B
W–B
(HAZ–) E8
Hazard Warning
Signal Switch
W–B
Assembly
W–B W–B
E35 (E) (–)
Turn Signal
Flasher Assembly
W–B
W–B
E14 (E)
Heater Control W–B
2 (4)
Assembly
W–B
IG Relay
W–B W–B
(–S) 2 2 (COL–)
FOG Relay
W–B
W–B
(–S) 2 (GND) E26
EFI MAIN Power Steering
Relay ECU Assembly
W–B
W–B
(EATH) 2
HTR Relay
E5
189
AVANZA (EM19Y0E)
I GROUND POINT
W–B
E15 (E)
Cigarette Lighter
Assembly or
Power Point
Socket Assembly
W–B W–B
E36 (E) (E) E12
Outer Mirror DLC3
Switch Assembly
W–B
W–B
(SIGE)
W–B
W–B
E30 (EW)
Windshield Wiper
Switch Assembly
W–B
W–B
(–) K4
(∗5) Map Light
Assembly
4
W–B W–B W–B
KE1 (–) K1
(∗6) Map Light
Assembly
10
W–B W–B
G6 (E) GE2
Power Window Regulator (LHD) (LHD) W–B
(RL+) E33
Master Switch Assembly Headlight Dimmer
Switch Assembly
10
W–B W–B W–B
F4
BR
W–B
(–) B13
Brake Fluid Level
Warning Switch
(Brake Master
Cylinder Reservoir
Sub–Assembly)
W–B
(–) B15
Engine
Hood Switch
W–B
E3
W–B
(–) B2
Fog Light
Assembly LH
W–B
W–B
(–) B1
Headlight
Assembly LH
W–B
W–B
(–) B3
Headlight
Assembly LH
W–B
(–) B12
Side Turn Signal
Light Assembly RH
W–B
W–B W–B
W–B
W–B W–B
(E) E4
Stereo Component
Tuner Assembly
E2 E1
190
AVANZA (EM19Y0E)
I
W–B
(–) J10
(LHD) Front Seat Inner
Belt Assembly LH
W–B
J4 (–)
Rear Combination
Light Assembly RH
W–B
3
W–B
W–B W–B
P1 (E) PJ1
Fuel with Motor &
Bracket Pump Assembly
1
BR BR 1 MJ1
(–) PJ1
W–B
(∗4)
W–B
J9 (–)
W–B
Rear Combination
(∗3)
Light Assembly LH BR
J2 J1
W–B W–B
(–) M1
(∗3) (∗3) Center Stop
Light Assembly
1 ML1
W–B
(–) L3
License Plate
Light Assembly LH
W–B
W–B
(–) L2
License Plate
Light Assembly RH
W–B
(–) L4
B Back Door
O1 (–)
Rear Window Defogger Lock Assembly
(Back Door Glass)
L1
O1
W–B
B10 (GND1)
Brake Actuator
Assembly
W–B
(GND2)
B1
191
AVANZA (EM19Y0E)
I GROUND POINT
: Parts Location
Code See Page Code See Page Code See Page
27 (LHD) E39 32 (RHD) 27 (LHD)
C25 E46
33 (RHD) 27 (LHD) 33 (RHD)
E43
E39 26 (LHD) 33 (RHD)
: Relay Blocks
Code See Page Relay Blocks (Relay Block Location)
2 23 Fuse Block Assembly (Lower Finish Panel)
: Ground Points
Code See Page Ground Points Location
37 (LHD)
A1
41 (RHD)
Cowl Side Panel RH
37 (LHD)
A2
41 (RHD)
37 (LHD)
B1 Cowl Side Panel LH
41 (RHD)
36 (LHD)
C1
40 (RHD)
Engine Unit
36 (LHD)
C2
40 (RHD)
37 (LHD)
E1
41 (RHD)
37 (LHD)
E2
41 (RHD)
37 (LHD)
E3 Instrument Panel Reinforcement
41 (RHD)
37 (LHD)
E4
41 (RHD)
37 (LHD)
E5
41 (RHD)
38 (LHD)
J1 Quarter Panel RH
42 (RHD)
38 (LHD)
J2 Center Body Pillar RH
42 (RHD)
38 (LHD)
L1
42 (RHD)
Back Door Panel
38 (LHD)
O1
42 (RHD)
192
AVANZA (EM19Y0E)
Memo
193
AVANZA (EM19Y0E)
J POWER SOURCE (Current Flow Chart)
The chart below shows the route by which current flows from the battery to each electrical source
(Fusible Link, Circuit Breaker, Fuse, etc.) and other Parts.
1 HTR Relay
40A HTR (Point Side) 2
10A (ECU-B)
10A BACK UP
10A HORN
10A STOP
Ignition or Starter
Switch Assembly (AM) E28
10A TAIL 1
15A EFI
30A RAD
50A EPS
1 Ignition or Starter
30A AM2 Switch Assembly (AM2) E28
10A H-LP LH
HEAD Relay
(Point Side) 1 1
10A H-LP RH
IG Relay
(Point Side) 2
15A (D/L)
40A IG1 1 2
10A HAZARD
1 FOG Relay
20A (FR FOG) (Point Side) 2
194
AVANZA (EM19Y0E)
J
Example
Starter S1
7.5A DRL 4
7.5A (HTR SUB) 2 Location
Electrical Source
10A ACC
7.5A IG1/BACK 2
15A (CIG)
20A (DEF)
10A E/G
7.5A ST
20A FR WIP
30A POWER
[LOCATION]
1 : Engine Room R/B Assembly and Engine Room J/B Assembly (See Page 22)
2 : Fuse Block Assembly (See Page 23)
195
AVANZA (EM19Y0E)
J POWER SOURCE (Current Flow Chart)
Engine Room R/B Assembly and Engine Room J/B Assembly
(See Page 22)
Fuse System Page
10A (A/C NO.1) Air Conditioner 184
10A (ECU-B) ECT and A/T Indicator and Engine Control 60
ABS 100
Audio System 168
Combination Meter 172
DLC3 74
ECT and A/T Indicator and Engine Control 60
10A BACK UP Engine Immobiliser System 72
EPS 108
Illumination and Taillight 90
Interior Light 96
Key Reminder and Light Reminder 120
Seat Belt Warning 118
10A H-LP LH Headlight 76
10A H-LP RH Headlight 76
Horn 162
10A HORN
Theft Deterrent 144
ABS 100
ECT and A/T Indicator and Engine Control 60
Interior Light 96
Shift Lock 116
10A STOP
Stop Light 88
Theft Deterrent 144
Wireless Door Lock Control (LHD) 132
Wireless Door Lock Control (RHD) 138
ECT and A/T Indicator and Engine Control 60
Front Fog Light 80
10A TAIL
Illumination and Taillight 90
Key Reminder and Light Reminder 120
Combination Meter 172
15A EFI
ECT and A/T Indicator and Engine Control 60
20A (FR FOG) Front Fog Light 80
30A (ABS NO.2) ABS 100
30A AM2 Starting 52
30A RAD Cooling Fan 182
40A (ABS NO.1) ABS 100
40A HTR Air Conditioner 184
* These are the page numbers of the first page on which the related system is shown.
196
AVANZA (EM19Y0E)
J
Fuse System Page
50A EPS EPS 108
197
AVANZA (EM19Y0E)
J POWER SOURCE (Current Flow Chart)
Fuse System Page
Door Lock Control (LHD) 124
Door Lock Control (RHD) 128
Engine Immobiliser System 72
Key Reminder and Light Reminder 120
10A HAZARD
Theft Deterrent 144
Turn Signal and Hazard Warning Light 82
Wireless Door Lock Control (LHD) 132
Wireless Door Lock Control (RHD) 138
15A (CIG) Cigarette Lighter or Power Outlet 164
Door Lock Control (LHD) 124
Door Lock Control (RHD) 128
15A (D/L) Theft Deterrent 144
Wireless Door Lock Control (LHD) 132
Wireless Door Lock Control (RHD) 138
15A (RR WIP) Rear Wiper and Washer 160
ECT and A/T Indicator and Engine Control 60
20A (DEF)
Rear Window Defogger 166
20A FR WIP Front Wiper and Washer 158
Power Window (LHD) 150
30A POWER
Power Window (RHD) 154
* These are the page numbers of the first page on which the related system is shown.
198
AVANZA (EM19Y0E)
Memo
199
AVANZA (EM19Y0E)
K CONNECTOR LIST
A1 A2 A3 A4
Black (Front Turn Signal) Gray (Low and High) Black (Clearance Light) Black
1
1
2 3
1 2 1 2
A5 A6 A7 A8 A9
Black Black Black Black Gray
2 1 1 2
1 2
1 2
1 2
A10 A11 B1 B2 B3
Black Yellow (Front Turn Signal) Gray Black (Clearance Light) Black
1 2
3 4 1 2
1 2 1 2 1 2
B4 B5 B6 B7 B8 B9
(Low and High) Black Gray Black Black Black Black
1
1
1 1 1 2
2 3 3 4
2 2
1 2
2 1 1 2
1 2 3 4 5 6 7 8 9 10 11 12
13 14 15 16 17 18 19 20 21 22 23 24
25 26 27 28 29 30 31 32 33 34
200
AVANZA (EM19Y0E)
K
B13 B14 B15 C1 C2
Black Yellow Black Black Black
1 2
1 2 3 4 1 2 3 4
1 2 1 2
C3 C4 C5 C6 C7
Black Black Brown Gray Brown
1 2 1 2 1 2
1 2 3 4 1 2 3 4
1 2
1 2 3
1 2 1 2 3
1 2
1
1 2 1
1 2 1 2
1 2
3 3 4
1 2 1 2 1 2
1 2 3 4 1 2 3 4 5 6 7
3 4
8 9 10 11 12 13 14 15 16 17
18 19 20 21 22 23 24 25 26 27
28 29 30 31 32 33 34
1 2
1 2 3 4 5 6 7 3 4
1 2 3 4 5 6 7
8 9 10 11 12 13 14 15 16 17 18 19
8 9 10 11 12 13 14
20 21 22 23 24 25 26 27
28 29 30 31 32 33 34 35
201
AVANZA (EM19Y0E)
K CONNECTOR LIST
C27 D1 D2 D3 E1 E2
Dark Gray
1 1
1
1 2 1
2 1
3 4
2
E3 E4 E5 E6
Gray
1 2 3 4 1 2
5 6 7 8 9 10 3 4 5 6
1 2 3 4 5 6 1 2 3 4 5 6 7 8 9 10
7 8 9 10 11 12 13 14 15 16 11 12 13 14 15 16 17 18 19 20
17 18 19 20 21 22 23 24 25 26 27
28 29 30 31 32 33 34 35
E7 E8 E9 E10
Black Black
1 2 3 4 5 1 2 3 4 5 6
1 2 5 6 1 2 3 4 5 6
3 4
7 8 9 10 11 12 13 14 15 16 7 8 9 10 11 12 13 14 15 16 17
17 18 19 20 21 22 23 24 18 19 20 21 22 23 24 25 26
1 2 16 15 14 13 12 11 10 9 1 2 3
1 2 2
8 7 6 5 4 3 2 1 4 5 6 7 8
1 2 3
4 5 6
1 2
1 2 1 2 3 4
3 4 5 6 7 8 1 2 3
202
AVANZA (EM19Y0E)
K
E21 E22 E23 E24
Dark Gray Dark Gray Dark Gray Black
1 2
1 2 3 4
1 2 3 4 3 4 5 6
5 6 7 8
5 6 7 8 1 2 3
9 10 11 12
1 2 1 2 3 1 2
1 1 2 3 4 5 6
3 4 4 5 6
7 8 9 10 11 12
2
1 2 3 4
1 2 5 6 7 8 9 10 11 12 13
1 2 3 4 5 6 7 8 9 10 1 2 3 4 5 6
7 8 9 10 11 12
1 2 3
4 5 6 7 8
1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 1 2 3 4 5 6 7 8 9 10
21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40
E37 E39
2 1
1 2 3 4
5 6 7 8 9 10 11
203
AVANZA (EM19Y0E)
K CONNECTOR LIST
E40
Blue
1 2 3 4 5 6 7 8 9 10 11
12 13 14 15 16 17 18 19 20 21 22
E41
Blue
1 2 3 4 5 6 7 8 9 10 11
12 13 14 15 16 17 18 19 20 21 22
E42
Brown
1 2 3 4 5 6 7
8 9 10 11 12 13 14
E43
1 2 3 4 5 6 7
8 9 10 11 12 13 14
E44
Blue
1 2 3 4 5 6 7
8 9 10 11 12 13 14
204
AVANZA (EM19Y0E)
K
E45
Blue
1 2 3 4 5 6 7
8 9 10 11 12 13 14
E46
Blue
1 2 3 4 5 6 7
8 9 10 11 12 13 14
E47
Blue
1 2 3 4 5 6 7
8 9 10 11 12 13 14
1 2 3
1 2
1 2 3 4 5 6 7
8 9 10 11 12 13 14
4 1
1 2 3 4 5 6 1 2
1 2 3 4 3 2 1 2 3 4 5 6 7
5 6 7 8 9
205
AVANZA (EM19Y0E)
K CONNECTOR LIST
E57 E58 E59 E60 E61
Yellow Yellow
1
1 2 1 2 3 4 5 1 2
2
6 7 8 9 10 11 12 13 14 15 16
1 2 3 4 5 6 7 8
9 10 11 12 13 14 15 16
17 18 19 20 21 22 23
E62 E63
Yellow
1 2 3 4 5 6 7 8 9 10 11 12 13 1 2 3 4
14 15 16 17 18 19 20 21 22 23 24 25
1 2 3 4
1 2 3 4 5 6 7
1 2 3 4
8 9 10 11 12 13 14
5 6 7 8
F1 F2 F3 F4 F5
Black
1 2 3 4 5
1 1 2 6 7 8 9 10 11 12 1 2
2 1
3 4 5 6
2 4 3
6 5
F6 F7 G1 G2 G3 G4
Black
1 1 2
1 2 3 4 5 1 2 2 1 1 2 3 4 5
2 4 3
6 5
206
AVANZA (EM19Y0E)
K
G5 G6 G7 H1 H2 H3
Black
1 2 3 4 5
6 7 8 9 10 11 12 1 2 1 1 2
1 2 1 2 3 4 5
3 4 5 6
2
H4 I1 I2 I3 I4 J1
Black
1 1 2 1
1 2 1 2 3 4 5 1 2
2
J2 J3 J4 J5 J6 J7
1
1 1
2 1 2 1
2 1
6 5 4 3
1
1 2
2 1 1 2 3 4 5 6 7 8 1 2 3 4 5
9 10 11 12 13 14 15 16 6 7 8 9 10
6 5 4 3
1 2 1 2
1 2 1 2 3 1 1 2
K4 K5 L1 L2 L3 L4
Black Gray Gray
1 2
1 2 1 2
1 2 3 4
1 2 3
1 2 3 4 5 6
4 5 6
7 8 9 10 11 12
207
AVANZA (EM19Y0E)
K CONNECTOR LIST
M1 N1 O1 P1 Q1 Q2
Gray Black Black Black Black Black
1 1 1 2 1 2
1 2 1 2 3
4 5
z1 z2 z3 z4 z5
Black
1 2
1 1 2 3 4 1 2 3 4 5 6 1 2 3 4 5 6
5 6 7 8 7 8 9 10 11 12
208
AVANZA (EM19Y0E)
Memo
209
AVANZA (EM19Y0E)
K CONNECTOR LIST
AE1 AE2 Black
1 2 2 1
3 2 1 3 4 5 6 6 5 4 3
1 2 3
1 2 3 4 5
6 7 8 9 10 11 12 13 1 2 3 4 5 5 4 3 2 1
5 4 3 2 1
13 12 11 10 9 8 7 6 6 7 8 9 9 8 7 6
10 11 12 13 14 15 16 17 17 16 15 14 13 12 11 10
2 1 1 2 3 4
4 3 2 1
1 2 2 1 5 6 7 8 9 10
1 2 10 9 8 7 6 5
1 2 3 4 5
6 7 8 9 10 11 12 13 1 2 3 4 5 5 4 3 2 1
5 4 3 2 1
13 12 11 10 9 8 7 6 6 7 8 9 9 8 7 6
10 11 12 13 14 15 16 17 17 16 15 14 13 12 11 10
1 2 2 1 2 1
3 2 1 3 4 5 6 6 5 4 3
1 2 3 1 2
210
AVANZA (EM19Y0E)
K
CE1 EE1 EE2
1 2 3
4 5 6 7 8
3 2 1 5 4 3 2 1
1 2 3 4 5
8 7 6 5 4 1 2 3 4 5 5 4 3 2 1
6 7 8 9 10 10 9 8 7 6
4 3 2 1
1 2 3 4 5 6 7 8 9 9 8 7 6 5 4 3 2 1
1 2 3 4
10 11 12 13 14 15 16 17 18 18 17 16 15 14 13 12 11 10
FE2 FJ1
1 2 2 1
1 2 3 4 5 5 4 3 2 1
3 4 4 3
6 7 8 9 10 10 9 8 7 6
GE1 GE2
1 2 3 4 5 6 7 8 9 9 8 7 6 5 4 3 2 1
1 2 3 4 5 5 4 3 2 1
10 11 12 13 14 15 16 17 18 18 17 16 15 14 13 12 11 10
6 7 8 9 10 10 9 8 7 6
1 2 3 1 2 3
4 5 6 7 8 4 5 6 7 8
3 2 1 3 2 1
1 2 2 1
8 7 6 5 4 8 7 6 5 4
3 4 4 3
211
AVANZA (EM19Y0E)
K CONNECTOR LIST
JE1 JE2 Gray
1 2 3 4 5 6 7 8 9 9 8 7 6 5 4 3 2 1
1 2 3 4 5 5 4 3 2 1
10 11 12 13 14 15 16 17 18 18 17 16 15 14 13 12 11 10
6 7 8 9 10 10 9 8 7 6
1 2 3 4 5 6 7 7 6 5 4 3 2 1
1 2 3 4 5 5 4 3 2 1
8 9 10 11 12 13 14 14 13 12 11 10 9 8
6 7 8 9 10 10 9 8 7 6
1 2 3
4 5 6 7 8 1 1
3 2 1
1 2 3 4 5 5 4 3 2 1 8 7 6 5 4
6 7 8 9 10 10 9 8 7 6
PJ1 QJ1
2 1
1 2
4 3 1 2 2 1
3 4
3 4 4 3
212
AVANZA (EM19Y0E)
Memo
213
AVANZA (EM19Y0E)
L PART NUMBER OF CONNECTORS
Code Part Name Part Number Code Part Name Part Number
A1 High Pitched Horn Assembly 90980-10619 C18 With Pulley Compressor Assembly 90980-10252
A2 Headlight Assembly RH 90980-11019 C19 Idle Speed Control Actuator Assembly 90980-11964
A3 Headlight Assembly RH 90980-11314 C20 Purge VSV 90980-11156
A4 Headlight Assembly RH 90980-11156 C21 Cam Timing Oil Control Valve Assembly 90980-11162
A5 Fog Light Assembly RH - C22 Oxygen Sensor (Bank 1 Sensor 1) 90980-10869
A6 With Motor Fan Assembly 90980-10928 C23 ECM 90980-12456
Brake Fluid Level Warning Switch C24 ECM 90980-12454
A7 (Brake Master Cylinder Reservoir 90980-11207
Sub-Assembly) C25 Junction Connector -
A8 Front Speed Sensor RH 90980-12627 C26 Oxygen Sensor (Bank 1 Sensor 1) 90980-11178
A9 Side Turn Signal Light Assembly RH 90980-11162 C27 Oxygen Sensor (Bank 1 Sensor 2) 90980-10869
Note:Not all of the above part numbers of the connector are established for the supply.
214
AVANZA (EM19Y0E)
L
Code Part Name Part Number Code Part Name Part Number
E33 Headlight Dimmer Switch Assembly 90980-12007 Front Power Window Regulator Switch
G4 90980-10789
Assembly LH
E34 Combination Meter Assembly 90980-12557
G5 Front Door Lock Assembly LH 90980-10825
E35 Turn Signal Flasher Assembly 90980-10799
Power Window Regulator Master Switch
E36 Outer Mirror Switch Assembly 90980-11657 G6 90980-10803
Assembly
E37 No. 1 with Box Speaker Assembly RH 90980-11060 G7 Front Door Lock Assembly LH 90980-10797
E39 Junction Connector 90980-11539 Rear Stereo Component Speaker Assembly
H1 -
E40 Junction Connector RH
90980-11915 Rear Power Window Regulator Motor
E41 Junction Connector H2 90980-11900
Assembly RH
E42 Junction Connector
Rear Power Window Regulator Switch
H3 90980-10789
E43 Junction Connector Assembly RH
E44 Junction Connector H4 Rear Door Lock Assembly RH 90980-10825
E45 Junction Connector - Rear Stereo Component Speaker Assembly
I1 -
LH
E46 Junction Connector
Rear Power Window Regulator Motor
E47 Junction Connector I2 90980-11900
Assembly LH
E48 Junction Connector Rear Power Window Regulator Switch
I3 90980-10789
E49 Back-Up Light Switch Assembly 90980-11075 Assembly LH
E52 No. 1 Stereo Jack Adapter Assembly 90980-12849 J1 Front Courtesy Light Switch RH 90980-10871
E53 Stereo Component Tuner Assembly 90980-12916 J2 Rear Speed Sensor RH 90980-11060
E54 Spiral Cable Sub-Assembly 90980-11986 J3 Rear Courtesy Light Switch RH 90980-10871
E55 Spiral Cable Sub-Assembly 90980-11886 J4 Rear Combination Light Assembly RH 90980-10796
E57 Un-Lock Warning Switch Assembly 90980-10860 J6 Front Courtesy Light Switch LH 90980-10871
E58 Transponder Key ECU Assembly 90980-12423 J7 Rear Speed Sensor LH 90980-11060
E59 Ash Receptacle Light Sub-Assembly J8 Rear Courtesy Light Switch LH 90980-10871
- J9 Rear Combination Light Assembly LH 90980-10796
E60 Airbag ECU Assembly
Airbag Squib J10 Front Seat Inner Belt Assembly LH 90980-10860
E61 (Instrument Panel Passenger Airbag 90980-11886 Option Connector
Assembly) J11 90980-12553
(Rear Clearance Warning ECU Assembly)
E62 Door Control Receiver 90980-11877 Option Connector
J12 90980-11537
E63 Spiral Cable Sub-Assembly 90980-12160 (Theft Warning ECU Assembly)
F2 Outer Rear View Mirror Assembly RH 90980-11587 K2 No. 1 Room Light Assembly 90980-10935
Front Power Window Regulator Motor K3 Rear Cooling Unit Assembly 90980-10860
F3 90980-11900
Assembly RH K4 Map Light Assembly 90980-12552
Power Window Regulator Master Switch Option Connector
F4 90980-10803 K5 90980-12012
Assembly (Room Light Assembly No. 2)
F5 Front Door Lock Assembly RH 90980-10797 L1 Rear Wiper Motor Assembly 90980-10355
Front Power Window Regulator Switch L2 License Plate Light Assembly RH
F6 90980-10789
Assembly RH 90980-11148
L3 License Plate Light Assembly LH
F7 Front Door Lock Assembly RH 90980-10825
L4 Back Door Lock Assembly 90980-11885
G1 Front No. 3 Speaker Assembly LH -
M1 Center Stop Light Assembly 90980-11148
G2 Outer Rear View Mirror Assembly LH 90980-11587
N1 Rear Window Defogger (Back Door Glass)
Front Power Window Regulator Motor 90980-11853
G3 90980-11900 O1 Rear Window Defogger (Back Door Glass)
Assembly LH
P1 Fuel with Motor & Bracket Pump Assembly 90980-11077
215
AVANZA (EM19Y0E)
L PART NUMBER OF CONNECTORS
Code Part Name Part Number
Option Connector
Q1
(No. 1 Ultrasonic Sensor LH)
90980-11246
Option Connector
Q2
(No. 1 Ultrasonic Sensor RH)
Power Steering ECU Assembly
z1 Power Steering Motor 90980-12299
(Steering Column Assembly)
Power Steering ECU Assembly
z2 Power Steering Torque Sensor 90980-12221
(Steering Column Assembly)
Spiral Cable Sub-Assembly
z3 90980-12222
Steering Wheel Sub-Assembly
Spiral Cable Sub-Assembly
z4 90980-11986
Horn Button Assembly
Spiral Cable Sub-Assembly
z5 Driver Side Squib Circuit 90980-12219
(Horn Button Assembly)
Note:Not all of the above part numbers of the connector are established for the supply.
216
AVANZA (EM19Y0E)
Memo
217
AVANZA (EM19Y0E)
* The system shown here is an EXAMPLE ONLY. It is different to the
HOW TO READ THIS SECTION actual circuit shown in the wiring diagram section.
218
[A]
Starting Engine Control
1 2 3 4
B- R B- R
B-R
ACC
2
[M]
W 4 AM1 IG1
B-W
A11
1 (BAT) Oxygen Sensor
ST1 1 B-W
7. 5A 15A
IGN EFI
8 AM2 IG2 7 B-R [L]
2 2
ST2 2 B-L
2 3 1
(2L-T) 2 2
GR
W-R
[B] A
B
A6
R-Y
R-Y R-Y
B-W
Ignition or Starter
Switch Assembly B-L B
B
R-Y
C
[E] 1 1
B-R
3 4
[H]
W EFI MAIN
B-L
(2L-T)
(2L-T) 7 BA3 Relay 12 BA1 [J]
B
[C]
Y-R
(Shielded)
1 2
W
W-R
1 A 1 B
B-R
[I] 1 1
2 2 A40(A), A41(B)
Starter
Relay
Y-R
B- W
21
Y-R Y-R Y-R
B-W
W-B
(22R-E)
2 2 BA3 D
2 A 2 B
Y-R
Y-R
2 3 7 3C
B-W
W-B
(2L-T)
(2L-T)
B-W
6 AB3
[F] 8 4
40A AM1
30A AM2
100A ALT
B-W
AVANZA (EM19Y0E)
+B OX1
M OVERALL ELECTRICAL WIRING DIAGRAM
A19
Circuit Opening
Relay
(22R-E)
[G] 1 6 15 3C
B-W
1
B-R
R-G
(2L-T)
B-R B-R B-R FP E1
Emission ECU
<9-8>
B1
DLC1
B-W
2 5 AD2 [D] 1 3
B-R
B-R
B-R
B-R
1 A
R-G
R-G
W-B
2 2 2 2
B
R-G
16 AD1
B 1
B M
17 BA3
B9
Fuel Injector
Assembly No.1
B11
Fuel Injector
Assembly No.2
B10
Fuel Injector
Assembly No.3
B12
Fuel Injector
Assembly No.4
R-G
1 1 1 1
B38(A), B39(B)
BR
BR
Starter Assembly
2
R-G
W-R
W-R
W-R
W-R
E
1 W-R W-R
F
W-B
W-B
[K]
A1 A1 A3 B1
[A] : System Title [E] : Indicates a Relay Block. No shading is used and
[B] : Indicates the wiring color. only the Relay Block No. is shown to distinguish
it from the J/B.
Wire colors are indicated by an alphabetical code. Example: Indicates Relay Block No.1
Copper wires
B = Black W = White BR = Brown [F] : Junction Block (The number in the circle is the J/B No.
and the connector code is shown beside it).
L = Blue V = Violet SB = Sky Blue Junction Blocks are shaded to clearly separate them
R = Red G = Green LG = Light Green from other parts.
P = Pink Y = Yellow GR = Gray
Example:
O = Orange BE = Beige DG = Dark Gray
Aluminum wires 3C indicates that
it is inside
LA = Lavender Junction Block
No.3
NOTICE : Do not splice into aluminum wires for power sources
or signals.
The first letter indicates the basic wire color and the
second letter indicates the color of the stripe.
Example: L–Y [G] : Indicates related system.
[H] : Indicates the wiring harness and wiring harness
connector. The wiring harness with male
terminal is shown with arrows ( ).
Outside numerals are pin numbers.
L Y
(Blue) (Yellow)
[C] : The position of the parts is the same as shown in
the wiring diagram and wire routing.
AVANZA (EM19Y0E)
[D] : Indicates the pin number of the connector.
The numbering system is different for female and Female Male ( )
male connectors.
[I] : ( ) is used to indicate different wiring and
Example: Numbered in other Numbered in other
from upper left to from upper right to connector, etc. when the vehicle model, engine type,
lower right lower left or specification is different.
[J] : Indicates a shielded cable.
Female Male
[K] : Indicates a ground point.
The numbering system for the overall wiring diagram is
the same as above [L] : The same code occurring on the next page indicates
that the wire harness is continuous.
[M] : Indicates the ignition key position(s) when the power is
M
219
SYSTEM INDEX
220
SYSTEMS LOCATION SYSTEMS LOCATION
ABS .................................................................................................. 14-1 Starting ............................................................................................... 3-1
Air Conditioner .................................................................................. 27-1 Stop Light ......................................................................................... 11-2
Audio System ................................................................................... 25-1 Taillight ............................................................................................. 12-1
Back-Up Light ................................................................................... 11-1 Theft Deterrent (LHD) ....................................................................... 18-4
Charging ............................................................................................. 4-1 Theft Deterrent (RHD) ...................................................................... 19-4
Cigarette Lighter ............................................................................... 23-2 Turn Signal and Hazard Warning Light ............................................ 10-1
Combination Meter ........................................................................... 26-1 Wireless Door Lock Control (LHD) ................................................... 18-3
Cooling Fan ...................................................................................... 23-4 Wireless Door Lock Control (RHD) ................................................... 19-3
DLC3 .................................................................................................. 8-1
Door Lock Control (LHD) .................................................................. 18-1
Door Lock Control (RHD) ................................................................. 19-1
ECT and A/T Indicator ........................................................................ 6-9
Engine Control .................................................................................... 6-1
Engine Immobiliser System ................................................................ 7-1
EPS .................................................................................................. 16-1
Front Fog Light ................................................................................... 9-3
Front Wiper and Washer .................................................................. 22-1
Headlight ............................................................................................ 9-1
Horn .................................................................................................. 23-1
Ignition ................................................................................................ 5-1
Illumination ....................................................................................... 12-1
Interior Light ...................................................................................... 13-1
AVANZA (EM19Y0E)
M OVERALL ELECTRICAL WIRING DIAGRAM
P o w e r S o u rc e
1 2 3 4
15A (CIG)
30A AM2 1 2
6
1 2 B B 5 AM2 IG2 6 P
1 AE2
7. 5A ECU IG1
ST 4 L–B
10A H–LP LH G 1 2
HEAD Relay 2
5 3 1 2 E28
Ignition or Starter 7. 5A IG1/BACK
Switch Assembly
1 2 1 2 B–W
2
10A H–LP RH
1 2 1 2
HTR Relay
2 1
40A HTR 7. 5A (HTR SUB)
5 10A ECU IG2
1 2 G G 5 3 L 1 2
1 AE2 2 2 2 P 1 2
2
4
30A RAD 10A HAZARD
10A E/G
1 2 2 1 2
1 2
15A (D/L)
W–B
10A (A/C NO. 1) 7. 5A ST
R 1 2
1 2 2 L–B 1 2
2 4
20A FR WIP
E42
Junction Connector
2
1 2
W–B
AVANZA (EM19Y0E)
2
40A IG1 15A (RR WIP)
4
1 1
B 1 2 R R 5 3 B B 1 2
1B 1 AE1 2 2 2
R–W
50A EPS
R–W 2 1 W–B 10A (A/C NO. 2)
1 2 2 2
10A STOP
IG Relay 1 2
B
1 2
W–B
10A TAIL 1 2
1 2
10A HORN 7. 5A (FR FOG RH)
Battery
15A EFI 1 2 1 2
4
1 2 2 1 E39
Junction Connector
20A (FR FOG) 7. 5A (FR FOG LH)
5
1 2 W–R W–R 3 5 V 1 2 E4
1 AE4 2 2 2
FOG Relay
M
221
2 AVANZA
222
M u ltip le x C o m m u n ic a tio n S y s te m (C A N ) ∗ 1 : w/o Multi Information Display
∗ 2 : w/ Multi Information Display
1 2 3 4
E3(C)
ECM
B
W
R
G
R
R
(A/T ∗2)
(A/T ∗2)
(A/T ∗1)
(A/T ∗1)
(M/T ∗2)
E45
6 14 8 10 Junction Connector
CANH CANL
9 11 1 3
E12
DLC3
P
B
G
LG
(A/T ∗2)
(A/T ∗2)
(A/T ∗2)
(A/T ∗2)
(M/T ∗2)
7 A 17 A
AVANZA (EM19Y0E)
CANH CANL
M OVERALL ELECTRICAL WIRING DIAGRAM
E9(A)
Transmission
Control ECU Assembly
28 29
CANH CANL
E34
Combination Meter Assembly
3 AVANZA
S ta rtin g
1 2 3 4
B
(A/T)
B 5 AM2 IG2
(A/T)
ST 4 L–B
E28
B
L–W
(A/T)
(A/T)
Ignition or
Starter Switch
Assembly
B
B
L–B
L–B
L–B
(A/T)
(A/T)
(A/T)
(M/T)
(M/T)
2
2 2
1 3 2
ST
7. 5A Relay
ST
6 AE2 2 AE2 5 1
2
2 2
B
L–B
1 1 B
(A/T)
L–W
L–W
(A/T)
(M/T)
2
1 1C
30A
AM2
ECM
< 6–4>
1
AVANZA (EM19Y0E)
L–B
1 1B
Transmission Control
ECU Assembly< 6–11>
B
1 B
FL MAIN
2. 0L
B–R 1 D1(A), D3(B)
A M Starter Assembly
Battery
M
223
4 AVANZA
224
C h a rg in g
1 2 3 4
(IG)
10A
ECU IG2
LG
(A/T)
2
LG
(M/T)
E43
Junction
Connector
9
R–L
2
(A/T)
R–L 9
(M/T)
E48
Junction
Connector
39
IG
Charge
B
CHG
E34
Combination
Meter Assembly
36
1 1B
R–W
ECM
< 6–4>
1 1A
4 CE1
AVANZA (EM19Y0E)
M OVERALL ELECTRICAL WIRING DIAGRAM
B
B–W
R–W
1 B 4 A 2 A
B L IG
B
FL MAIN
2. 0L
IC Regulator
Battery
C16(A), D2(B)
Generator Assembly
225 AVANZA (EM19Y0E)
5 AVANZA
4
1
W–B W–B W
–
+
C2
3
B
2
IGT
C1
Ignition Coil
Assembly No. 1
W–B
4
1
2
W–B W W W
–
2
+
(IG)
2 CE1
E/G
10A
R
IGT
W
C2
Ig n itio n
Ignition Coil
Assembly No. 2
W–B
ECM
< 6–5>
4
1
W–B W
–
+
G
IGT
3
C3
Ignition Coil
Assembly No. 3
4
1
W–B W
–
+
3
L
IGT
C4
Ignition Coil
Assembly No. 4
4
M
6 AVANZA (Cont. next page)
226
∗ 5 : Thailand
∗ 6 : Except Thailand
∗ 7 : w/ Engine Immobiliser System
E n g in e C o n tro l ∗ 8 : w/o Engine Immobiliser System
∗ 9 : Mexico
1 2 3 4
(IG) (BAT)
10A 15A L L L L L
E/G EFI
2 2
L
L
L
L
L
2 1
C11
1 1 1 1 2 2 Vacuum Sensor
W
LG
W
– VC PIM
C5
Fuel Injector
Assembly No. 1
C6
Fuel Injector
Assembly No. 2
C7
Fuel Injector
Assembly No. 3
C8
Fuel Injector
Assembly No. 4
C20
Purge VSV
C21
Cam Timing Oil Control
Valve Assembly
2 2 2 2 1 1 1 3 2
9 AE4
W
ST Fuse< 3–3>
Generator Assembly
< 4–3>
Stop Light Switch
Assembly< 11–3>
B
W
LG
L
P
V
B
P
R
G
W
LG
LG
W–R
R–W
L
W
G
L–W
B–W
2 2 2 2
4 A 3 A 2 A 1 A 24 A 7 A 7 C 6 A 5 A 35 B 17 B 12 B 25 C 34 A 12 C
3 2 3 2 # 10 # 20 # 30 # 40 PRG +B1 BAT OCV+ OCV– E2PM VCPM PIM STA ALT STP
C23(A), C24(B), E3(C)
ECM
EFI MAIN
Relay
F/P Relay
FC2 FC1 SL IAHI IALO IBHI IBLO AUX1 E21 THA THW VC VTHO E2 KNK OX OXH1
5 1 5 1 17 C 18 C 23 C 15 A 14 A 17 A 16 A 8 C 31 C 15 B 14 B 16 B 23 B 33 B 13 B 11 B 3 B
2 2 2 2
R–G
V
P
V
B
LG
BR
BR
(∗7)
(∗8)
L–R
R–B
W–L
L
B–W
B–W
B–W
(A/T)
G–W
G–W
10 A
LG–R
(Shielded)
(Shielded)
L
W–B
E40(A)
Junction
Connector
5 JE1 11 A
3 A 1 A (∗6)
1 CE1 4 3 1 4 2 1 1 1 3 2 3 B 1 B (∗5)
W–L
B–W(∗8)
B–W(∗7)
AVANZA (EM19Y0E)
IAHI IALO IBHI IBLO VC PSW + HTR–
G–W
M OVERALL ELECTRICAL WIRING DIAGRAM
E46
Junction Connector
L
L
4 PJ1 3
2 E HTR+
C22(A), C26(B)
Oxygen Sensor
(Bank 1 Sensor 1)
4 A 2 A (∗6)
C14
Intake Air Temperature Sensor
C15
Engine Coolant
Temperature Sensor
C19 – 4 B 2 B (∗5)
2 2
C12
Throttle Position Sensor
C13
Knock Control
Sensor (Bank 1)
W–L
Actuator Assembly
E1
Resistor
4
1
L
BR
BR
BR
BR
BR
BR BR BR BR BR
L
P1 A
W–B
M (∗5, ∗9)
Fuel with Motor &
Bracket Pump Assembly
Fuel Suction
Pump
L
E B
(∗5, ∗9)
5
(Shielded)
C
W–B
3 PJ1
4 (Shielded)
11 W–B D
W–B
(A/T)
E39
Junction
Connector
J2 E4
6 AVANZA (Cont' d) (Cont. next page)
∗ 1 : w/o Multi Information Display
∗ 3 : w/ Rear Window Deffoger
E n g in e C o n tro l ∗ 5 : Thailand
∗ 9 : Mexico
5 6 7 8
Power Steering
ECU Assembly< 16–2>
Airbag ECU
Assembly< 15–3>
RAD Relay
< 23–4>
Combination Meter
Assembly< 26–4>
Rear Window Defogger
Switch Assembly< 23–3>
Combination Meter
Assembly< 26–2>
Headlight Dimmer
Switch Assembly< 12–2>
L
L
P
B
R
G
G
(∗3)
(∗1)
P–L
V–R
W–L
R–W
LG–B
(M/T ∗1)
20 C 12 A 11 A 10 A 9 A 13 C 16 C 33 C 6 C 22 C 15 C 30 C 14 C 29 C 11 C 10 C 24 C
EPS IG1 IG2 IG3 IG4 FPOF FAN REV DEF SPD MGC ACVR ACEV ACSW BLW H/L ATNE
C23(A), C24(B), E3(C)
ECM
CANH CANL HCAN LCAN N2+ N2– N+ N– OX2 OXH2 E1 E01 T W SIO2
4 C 3 C 2 C 1 C 8 B 28 B 9 B 29 B 24 B 13 A 32 B 7 B 26 C 27 C 32 C
W
(∗5, ∗9)
LG
P–B
W–B
W–B
V–W
13
G
W
W
L–R
E64
Junction
Connector
(∗5, ∗9)
(∗5, ∗9)
(∗5, ∗9)
(Shielded)
(Shielded)
(Shielded)
14
DLC3
< 8–3>
AVANZA (EM19Y0E)
3 1
1 1
LG–B
+(∗5) IREL(∗5)
OX2(∗9) OXH2(∗9)
Multiplex Communication
System (CAN)< 2–2>
E(∗5) ECHI(∗5)
E2(∗9) +B(∗9)
C9
Cam Position
Sensor
C10
Crank Position
Sensor
C27
Oxygen Sensor
(Bank 1 Sensor 2)
2 2 4 2
L
BR
(∗5, ∗9)
(∗5, ∗9)
BR
A
(∗5, ∗9)
Transponder Key
ECU Assembly< 7–3>
L
B
(∗5, ∗9)
2 9 3
(Shielded) 1 C25
C Junction
Connector
8 4 11
W–B V–W
BR
B
W–B
(Shielded) BR
D
C1
M
227
6 AVANZA (Cont' d) (Cont. next page)
228
E C T a n d A /T In d ic a to r
9 10 11 12
L
(BAT) A
10A
(ECU–B)
L–B
W–L
A 4 AE4
L–B
E47
Junction
7 Connector
Multiplex Communication
System (CAN)< 2–2>
DLC3
< 8–2>
ST Relay
< 3–3>
Combination Meter
Assembly< 26–2>
B–Y
13 14 B
L–W
G
C
W–L
L
V
B
D
(∗1)
(∗1)
L–W
B–Y
L–W
8 A 2 A 1 A 24 A 16 A 17 A 7 A 11 A 3 A 24 B 16 B 25 B
RENG BAT BAT2 T STR CANL CANH SPD0 +B P N 2 L
E9(A), E10(B)
Transmission Control ECU Assembly
OTMP ETMP B1+ B1– C2+ C2– C3B+ C3B– LUCC LUCR SOLR VBTB ETBN RTBN EITB VBOP EOPT ROTP EIOP E01 E1 E02 W ODL MODE R P D ODCS
AVANZA (EM19Y0E)
M OVERALL ELECTRICAL WIRING DIAGRAM
14 B 13 B 6 B 5 B 4 B 3 B 2 B 1 B 22 B 11 B 12 B 9 B 20 B 10 B 21 B 7 B 18 B 8 B 19 B 6 A 4 A 5 A 13 A 20 A 12 A 23 A 15 B 23 B 21 A
P
V
B
G
W
LG
LG
BR
BR
BR
(∗1)
(∗1)
(∗1)
L–R
B–Y
R–B
G–B
G–Y
W–L
R–W
W–R
W–R
LG–B
8 12 7 11 5 9 6 10 2 3 4 R–B
B
R
W
E
L–W
8 2 9
B–W
G–W
H5 H9 H6 H10 H8 H12 H7 H11 H3 H2 H1 (Shielded)
(Shielded)
G–Y
L
Y
B
R
R
R
G
W
BR
F
GR
E46 LG
1 G
1 3 2 1 3 2 Junction
Connector W–R
VCC GND VOUT VCC GND VOUT
H
W–B
B–Y
I
(∗1)
8 CE1
E20 E22 LG–B(∗1)
Transmission Revolution Transmission Revolution
J
Sensor (Turbine) Sensor (Output) G–B(∗1)
E21
ECT Solenoid (Solenoid Wire)
K
W–B
V–W V–W
B L
C2
6 AVANZA (Cont' d)
13 14 15 16
L
A (IG)
E23
Park/Neutral Position Switch Assembly (BAT)
10A
+ P – N D 2 L E ECU IG2
10A
P BACK UP
2
R
2 2
N
1
D
LG
LG
(A/T)
(M/T)
B–W
2
2 2
L L 8
8 AE4
7 4 1 5 3 2 8 6
E43
Junction
Connector
E48
Junction
Connector
9 9
V
B
BR
B–W
R–W
R–L
R–L
R
(A/T)
(M/T)
E34
40 Combination Meter Assembly 39
+B IG
Back–Up Light
System< 11–1>
Back–Up Light
System< 11–1>
5
B–Y 6
B
E46
Junction
Connector
6 4
12 LCD
L–W 12
C
V 10
D
E47
Junction
Connector
AT
5 3
10
CPU
Check Engine
(∗1)
(∗1)
B–L
W–G
E46
Junction
Connector
L
E46 3
(∗1)
R–Y
Junction (∗2)
4 Connector (∗2)
(∗1)
14 13
NSSD
Back–Up Light
System< 11–1>
(∗2)
L 2 3 N P D R+ E WNG EFI
AVANZA (EM19Y0E)
7
W–B
E47 27 26 25 23 22 24 7 16 31 37
Junction
Transmission
Control
Switch
Connector 2
A/T3 ATD
E18
Transmission Floor
Shift Assembly
G
BR
(∗1)
(∗1)
(∗1)
(∗1)
(∗1)
(∗1)
(∗1)
B–Y
P–B
R–Y
G–B
V–W
W–G
LG–B
1 2
R–B
E 9 8
(∗1)
P–B
G–Y
G
(∗1)
W–R
F
LG
G
W–R
H
B–Y
I
(∗1)
LG–B(∗1)
J
G–B(∗1)
K
V–W
L
5
11 E39
Junction
Connector
E4
M
229
7 AVANZA
230
E n g in e Im m o b ilis e r S y s te m
1 2 3 4
(BAT) (IG)
10A 10A
BACK UP ECU IG2
2 2
1 2
B–W
ECM
< 6–8>
DLC3< 8–3>
8 AE4
L–R
LG–B
R–L
B–W
1 2 9 10
+B IG SIO2 SIO
E58
Transponder Key ECU Assembly
LG
BR
L–W
B–W
R–W
AVANZA (EM19Y0E)
M OVERALL ELECTRICAL WIRING DIAGRAM
DLC3
< 8–2>
1
COL+
Un–Lock Warning
Switch Assembly
< 18–4> < 19–4>
Door Control
Receiver< 18–4> < 19–4>
COL–
E56
Transponder Key Coil
7
10
E39
Junction
Connector
E4
231 AVANZA (EM19Y0E)
8 AVANZA
8
4
2
16
E4
+B
8 AE4
(BAT)
E39
2
10A
Junction
5
Connector
W–B
BACK UP
B–W Transponder
SIGE
Key ECU
(∗5) Assembly< 7–3>
3
Power Steering L
12 A
Connector
E40(A), E41(B)
16 B
16 A
DLC3
17 B
18 A
SIO
17 A
E40(A), E41(B) V–W V–W Brake Actuator
4 BE4
Connector
Transponder L–R
Key ECU Assembly< 7–3> (∗5)
12
14
ECM LG
EFIT
< 6–7>
CANL
Multiplex Communication
System (CAN)< 2–2>
9
6
Combination Meter R–W
REV
Assembly< 26–4>
CANH
∗
∗
∗
∗
∗
5
4
3
2
1
4
: w/ ABS
: w/ SRS
: w/ Multi Information Display
: w/o Multi Information Display
232
H e a d lig h t F ro n t F o g L ig h t
1 2 3 4
(BAT)
B
20A
(FR FOG)
1 1B
B
2
1 5 1 1
1
FL MAIN
2. 0L HEAD
Relay 10A 10A
H–LP LH H–LP RH
W–R
2 3
2 2 5 AE4
V
1 1 1
R
2
Battery
L
R
R
B–W
W–R
2 A (LHD)
1 B (RHD)
12 AE4 4 AE2 1 1 2 2 L
7. 5A 7. 5A 3 2 FFG BFG
L
(FR FOG LH) (FR FOG RH)
B–W
OFF
FOG
Front Fog
Light
Switch
2 2 Relay
P
On
12 A (LHD) 5 BE3
6 B (RHD) 2
5 1
2 2 B
B +
L
E33(A), (B) 4 A (LHD)
2 2 Headlight Dimmer 3 B (RHD)
3 3 Switch Assembly
T ET H EL H EL HL HU
B4 A3
Headlight Headlight
V
OFF Flash
L–R
High Beam
W–B
V–W
G–W
Assembly LH Assembly RH
Tail Low 2 1 2 1
Light
Control Switch
Dimmer Switch
E
E34
Combination Meter Assembly
Head High
16
B
P
B
P
4 BE3 11 AE3
AVANZA (EM19Y0E)
13 BE3 12 BE3 5 AE3 4 AE3
M OVERALL ELECTRICAL WIRING DIAGRAM
E LO HI
L–R
G–W
Switch Assembly
2 2
P
B
B
P
B
P
BR
W–B
B
1 1
B2
Fog Light
Assembly LH
A5
Fog Light
Assembly RH
W–B
W–B
10 BE3
5 4
W–B
E39
Junction
Connector
E39
Junction
Connector
E3 E4 E1 A2 E4
233 AVANZA (EM19Y0E)
Turn
Signal
Switch
E33(A), (B)
10 AVANZA
Switch Assembly
N
Headlight Dimmer
LH
RH
5
4
2
LH
L–B B
2
11 B
5 A
B
TL
EL
(BAT)
1
RL+
W–B
10A
TB
HAZARD
RH
6 A (LHD)
P
12 B (RHD)
TR
ER
E35
1
1
4
2
7 A (LHD)
W–R B–W
13 B (RHD)
L
2
(IG)
E42
Junction
Connector
7. 5A
IG1/BACK
4
3
8
W–B B–R
Turn Signal Flasher Assembly
EHW
(∗4)
E8 E64
Hazard Junction
Warning Connector
Signal
6
12
G–W
LR
Door Control R
Receiver
< 18–4> < 19–4> (∗3)
8
4
7
3
5
BR
2
E4
E39 Side
Junction Turn
Connector
2
1
Light Assembly LH
L–W
Front
Turn
2
1
E1
10 BE3
3 BE3
–
+
(∗2)
B1
Headlight Assembly LH
L–W
Rear
Turn
5
3
J2
15 JE2
–
+
T u rn S ig n a l a n d H a z a rd W a rn in g L ig h t
J9
Rear Combination Light Assembly LH
3
Turn LH
BR
5
L–W
+
Turn RH
3
16
G–W
+
E
E34
Combination Meter Assembly
∗
∗
∗
∗
4
3
2
1
Side
Turn
2
1
W–B W–B G–W G–W
G–W
A2
–
+
(∗1) (∗1) (∗1) (∗1)
A9
Side Turn Signal
(∗1)
Light Assembly RH
G–W
: w/ Wireless Door Lock Control
: w/ Front Side Turn Signal Light
W–B
(∗1) Front
Turn
2
1
W–B G–W G–W
A1
10 AE3
–
+
(∗2)
4
A2
Headlight Assembly RH
Rear
Turn
5
3
W–B G–W G–W
J1
16 JE2
–
+
J4
Rear Combination Light Assembly RH
M
AVANZA (EM19Y0E) 234
R
11 AVANZA
7
8
4
2
LG B–W
2
+
(IG)
(A/T)
1
2
1
V–W P E42
–
–
+
(M/T) (M/T)
E49
J9 Back–Up Light
Rear Combination Switch Assembly
Light Assembly LH
V–W
B a c k – U p L ig h t
Back–Up
5
4
W–B V–W
J1
–
+
J4
Rear Combination
Light Assembly RH
2
2
1
6
5
2
B R P P
1
2 AE4
(BAT)
E48
E25
Junction
10A
Connector
STOP
Stop Light
Switch Assembly
13
B
E42
12
ECM G
< 6–4>
6
Stop
2
14
5
W–B
J2
–
Tail
∗
∗
∗
∗
4
3
2
1
J9
Rear Combination
Light Assembly LH
: w/ ABS
S to p L ig h t
BR
L–R
: w/ Center Stop Light
: w/o Center Stop Light
Stop
2
L–R L–R
5
5 MJ1
W–B W–B
+
(∗2)
J1
–
Tail
W–B
: Malaysia, Thailand w/ Steering Pad Switch
J4
Rear Combination
Light Assembly RH
1
MJ1
4
(∗3)
(∗2)
(∗2)
L–R
W–B
W–B
2
1
W–B W–B W–B L–R
L1
1 ML1
–
+
(∗2) (∗2) (∗2)
M1
Center Stop
Light Assembly
M OVERALL ELECTRICAL WIRING DIAGRAM
Memo
V V
1
5 B
13 A
Tail
1 AE4
OFF
Head
(BAT)
Switch Assembly
Headlight Dimmer
12 AVANZA
T
10A
TAIL
LG
ET
10 A (LHD)
8 B (RHD)
1
40
B–W B–W
1
8 AE4
(BAT)
+B
CPU
10A
9
2
R–L LG
BACK UP
(M/T) (M/T)
E48
Junction
Connector
9
2
2
39
R–L LG
2
(IG)
(A/T) (A/T)
IG
E43
Pointer Junction
Illumination
10A
Connector
16
14
BR LG
E
ECU IG2
ILM+
LCD
Illumination
2
LG
BR
E34
Combination
Meter Assembly
LG
V–W Headlight Dimmer
21 A
15 B
Switch Assembly
(∗2) < 9–4>
5
6
5
2
1
14
BR W–B R–B P–L ECM
19 A
12 B
–
+
2
2
W–B 1 P–L G–Y
20 A
13 B
–
+
LG
E59
Ash Receptacle
Light Sub–Assembly
3
3
6
3
11
11
W–B GR W–L P–B
22 A
14 B
E4
(A/T) (A/T) (A/T) (∗3)
ILL–
ILL+
E46 E40(A), E41(B)
Junction Junction
Connector Connector
E18
Transmission Floor
Shift Assembly
4
2
1
W–B W–B LG
–
+
E39
E8
Hazard Warning Signal
Junction
LG
Switch Assembly
Connector
2
3
W–B LG
E
E14
Heater Control Assembly
z3(B)
P–B
2 B
2 A
(∗3)
IL+2
Steering
∗
∗
∗
∗
5 B
5 A
Pad Switch
4
3
2
1
EAU
LG
(∗3)
G–Y
W–G
B
A
C
(Cont. next page)
M OVERALL ELECTRICAL WIRING DIAGRAM
237 AVANZA (EM19Y0E)
B
A
C
LG
(∗3)
G–Y
W–G
6 B
EAU
W–B G–Y
7 A
E
10 A
E1
ILM+
∗ 3 : w/ Steering Pad Switch
E4(A), E5(B)
5
12 AVANZA (Cont' d)
W–B W–B LG LG
10 BE3
8 BE3
–
+
B3
Headlight Assembly LH
LG
Stop
5
W–B
J2
1
LG LG LG
10 JE1
Tail
J9
Rear Combination Light Assembly LH
LG
LG
Stop
5
W–B
J1
1
LG
+
6
Tail
J4
Rear Combination Light Assembly RH
2
1
W–B LG LG LG LG
L1
3 MJ1
3 ML1
L3
License Plate
Light Assembly LH
2
1
W–B LG
L2
License Plate
W–B Light Assembly RH
A2
Clearance
2
1
W–B W–B LG LG
A1
9 AE3
–
+
Illu m in a tio n a n d T a illig h t
A4
Headlight Assembly RH
7
8
M
AVANZA (EM19Y0E) 238
13 AVANZA
3
4
L4
Back Door
Lock Assembly
1
W–L W–L
4 MJ1
J1
Front Courtesy
Light Switch RH
W–L
W–L
J6
Front Courtesy
Light Switch LH
W–L
W–L
J3
Rear Courtesy
Light Switch RH
W–L
2
1
1
2
40
18 JE2
8 AE4
L
(BAT)
(∗2) (∗2)
+B
J8
Rear Courtesy
10A
(∗1)
(∗1)
Light Switch LH
Door
BACK UP
21
W
(∗4)
CTY
Door Control W
Receiver< 18–4> < 19–4> (∗3) E34
Combination Meter Assembly
K4
Map Light Assembly
In te rio r L ig h t
7
6
W–B L
–
+
(∗5) (∗5)
1
W–L
DR
(∗5)
2
Door Control W–L W–L B
Receiver DOOR
3
9 KE1
(∗3) (∗6) R
< 18–4> < 19–4>
3
DR
1
OFF
+
(∗6)
ON
–
K1
BR W–B W–B Map Light Assembly
E3
4 KE1
(∗6)
1
W–L
DOOR
2
5
2
12
LG LG LG P P
W–B
(∗8)
1
DR
10 KE1
2 AE4
OFF
+
(BAT)
(∗8)
ON
E48
8
K2 Junction
10A
E4
No. 1 Room Light Assembly Connector
STOP
E39
B
R
(∗7)
(∗7)
Junction
Connector
Option Connector
(Theft Warning
ECU Assembly)< 28–4>
∗
∗
∗
∗
∗
∗
∗
∗
8
7
6
5
4
3
2
1
: Malaysia
: Except Malaysia
: w/ Glasses Case
: w/o Glasses Case
4
19
12
LG P P P
1
FL1
1 BE5
1 BE1
3 AE2
+BS
(BAT)
1
30A
1
2
18
V
–
+
FL0
B11
(ABS NO. 2)
24
1 AE2
+BM
(BAT)
3 AE3
7 BE4
2 BE5 (LHD)
2 BE1 (RHD)
40A
1
2
6
+
FR0
8 AE3
6 BE4
A8
Front Speed Sensor RH
2
34
3 A
9 B
+IG
(IG)
5 BE4
E40(A), E41(B)
B10
Junction
Connector
5
L L L
7. 5A
4 JE2
RL1
13 BE4
ECU IG1
1
2
4
P P P
–
+
3 JE2
RL0
14 BE4
Brake Actuator Assembly
J7
Rear Speed Sensor LH
2
22
17
R R R
2 JE2
9 BE4
RR1
20
P–B
SIO
1
2
16
W W W
+
1 JE2
8 BE4
RR0
DLC3
J2 < 8–2> < 8–3>
Rear Speed Sensor RH
32
V–W
TC
B1
30
Sub–Assembly)< 26–4>
PKB
Parking Brake
Switch< 26–4>
13
W–B
GND2
23
B Combination Meter
BRL
Assembly< 26–3>
21
28
15 BE4
STP
40
B–W B–W
1
8 AE4
CPU
(BAT)
+B
10A
BACK UP
Brake
9
2
2
18
39
V–R R–L LG
2
(IG)
–
(A/T) (A/T)
IG
E43
ABS
10A
5
16
BR
Junction
E4
Connector
E
ECU IG2
E39
9
2
E34 R–L LG
Junction
Connector
Combination Meter Assembly (M/T) (M/T)
E48
4
Junction
Connector
M
15 AVANZA
240
SRS ∗ 1 : w/ Steering Pad Switch
∗ 2 : w/o Steering Pad Switch
1 2 3 4
(IG) (IG)
7. 5A 10A
ECU IG1 ECU IG2
2 2
1 2
LG
W–R
J14 J13 (A/T)
LG
9 9
E40(A), E41(B)
Junction
Connector
4 A P– P+ D– D+
SRH+ SRH– SLH+ SLH–
1 2 1 2
R–L
(M/T)
R–L
2 1 2 1
(A/T)
P
Y
Y–B
Y–R
Y–G
39
R
W
LG
R–W
IG
P
Y
R
W
LG
Y–B
Y–R
Y–G
R–W
9 A 7 B 8 B 6 B 5 B 12 A 13 A 14 A 20 A
IG1 PPC PPH PDC PDH SR+ SR– SL+ SL–
E60(A), E66(B)
Airbag ECU Assembly
SRS
AVANZA (EM19Y0E)
L
Y
V
Y–B
W–B
B–W
G–W
M OVERALL ELECTRICAL WIRING DIAGRAM
E34
Combination Meter Assembly
A/B E
6 EE2 1 A 2 A (∗2) 8 EE2 7 EE2 10 EE2 5 EE2 17 16
Y–R
Y–G
1 B 2 B (∗1)
E55(A), E63(B), z5(C)
D+ D–
Spiral Cable
L
V
Sub–Assembly
BR
B–W
G–W
2 C 1 C
1 2
P+ P–
z5(C)
ECM
< 6–6>
W–B
Driver Side Squib Circuit E61
(Horn Button Assembly) Airbag Squib
DLC3
< 8–3>
(Instrument Panel
Passenger Airbag
Assembly)
3 5
E39
Junction
Connector
E39
Junction
Connector
E4 E4
16 AVANZA
EPS
1 2 3 4
(BAT) (IG) (IG)
50A 7. 5A 10A
EPS ECU IG1 ECU IG2
2 2 2
1 2 2
B
W–R
LG
LG
(A/T)
(M/T)
3 AE1 9 B
2 2
DLC3
< 8–2> < 8–3>
E41(B)
Junction Connector
8 B
E48
Junction
Connector
E43
Junction
Connector
Combination Meter
Assembly< 26–4>
ECM
< 6–5>
9 9
B
R
R–L
R–L
(A/T)
(M/T)
L
P
B–Y
LG–B
E26(A), E27(B), z1(C), z2(D)
1 A 6 B 2 B 11 B 12 B 8 B Power Steering ECU Assembly 39
IGP IG SIO EPST REV IDUP IG
B–R
W–L
R
(RHD)
(RHD)
EPSW
E34
Combination Meter Assembly
B
R
15
(LHD)
(LHD)
z2(D)
Power Steering Torque Sensor
AVANZA (EM19Y0E)
(Steering Column Assembly)
z1(C)
Power Steering Motor
(Steering Column Assembly)
Combination Meter
Assembly< 26–2>
W–B
E5
M
241
17 AVANZA
242
R e m o te C o n tro l M irro r S h ift L o c k
1 2 3 4
(ACC) (IG) (ACC)
2 2 2
2 2 2
L
E36
LG
Outer Mirror Switch Assembly 8
B
2 2
Stop Light
Switch Assembly< 11–3>
E43
Junction
Connector
E48
Junction
Connector
1 8
Up
Operation
Switch
Left
Left/
Up
Right
Down
Right/
Down
G
L–W
V–W
E19
Shift Lock Control ECU 8 6 4
Left Right Left Right
IG ACC STP
Select Switch
HL HR VL VR C E
5 2 4 3 6 7
V
B
LG
W–B
R–W
G–W
SLS+ SLS– P E2 KLS+ E
5 1
R–W
GR
R–W
AVANZA (EM19Y0E)
V
B
LG
R–W
R–W
G–W
M OVERALL ELECTRICAL WIRING DIAGRAM
13
Shift Lock 2
4 GE2 5 GE2 3 GE2 (LHD) 3 FE2 2 FE2 7 FE2 (LHD) Solenoid KS0+
E43
Junction
Connector
KS0–
Switch Bracket Assembly)
E29
Key Inter Lock Solenoid
(Steering Column Upper with
1
BR
BR
V
R–W
R–W
G–W
BR
V(LHD)
B(RHD)
LG(RHD)
G–W(LHD)
1 5 3 5 1 3
H V C V H C
M M M M
8 6
E39 E39
Junction Junction
G2 F2 Connector Connector
Outer Rear View Outer Rear View
Mirror Assembly LH Mirror Assembly RH
E4 E4
18 AVANZA
W ire le s s D o o r L o c k T h e ft D e te rre n t
D o o r L o c k C o n tro l (L H D )
C o n tro l (L H D ) (L H D )
1 2 3 4
(BAT) ∗ 1 : w/ Wireless Door Lock Control (BAT) (IG) (BAT)
∗ 2 : w/o Wireless Door Lock Control
∗ 3 : w/ Engine Immobiliser System
15A 15A 7. 5A 10A
(D/L) (D/L) IG1/BACK HAZARD
2 2 2 2
2 2 2 2
B
B–W
R
(∗2)
(∗2)
(∗2)
Combination
Meter Assembly
< 26–4>
Transponder Key ECU
Assembly< 7–3>
E24 2
3 Door Control Relay 5 4
B LKSW ULSW
4
E57
Un–Lock Warning
Switch Assembly
1
(∗3)
L–B
R–W
E42
Junction
Connector
G
9
Turn Signal Flasher Assembly< 10–2>
Hazard Warning Signal
Switch Assembly< 10–2>
Transponder Key ECU
Assembly< 7–3>
Combination Meter
Assembly< 13–2>
1 9 8
2 E64
Junction
Connector
P
R
R
G
W
(∗1)
(∗1)
(∗3)
P–B
L–W
W–R
LOK+ U/L+ E
2 1 25 12 17 11 4 23
2 1 6
LKM ULM B IG CHR IMO CTY KYSW
P
P
B
G
G
E62
(∗2)
(∗2)
(∗2)
(∗1)
(∗1)
(∗2)
(∗2)
W–B
Door Control Receiver
G G G
UKS LKS E RMLP IND FSW HRN
P P P
6 18 15 14 3 19 16
L
B
V
(∗1)
L–R
R–G
W–L
W–B
(∗1)
P
P
G
G
9 BE3
8 JE1 3 JE1 17 GE2 8 GE2 14 GE2 12 GE2 34
B
AVANZA (EM19Y0E)
L
P
P
P
B
G
G
G
L–R
HORN
Relay< 23–1>
P 4 5 1 3 2
Security
Map Light
Assembly< 13–3>
No. 1 Room Light
Assembly< 13–3>
P
P
P
G
G
G
16 1
Lock
Unlock
G
BR
W–B
W–B
2 ML1 5 ML1
13 GE2 10 BE3
P
P
P
P
G
G
G
G
2 1 2 1 2 1 2 1
W–B
W–B
W–B
F7 I4 H4 L4 E1 E4 E1 E4 E1 E2
Front Door Rear Door Rear Door Lock Back Door Lock
Lock Assembly RH Lock Assembly LH Assembly RH Assembly
M
243
19 AVANZA
244
W ire le s s D o o r L o c k T h e ft D e te rre n t
D o o r L o c k C o n tro l (R H D )
C o n tro l (R H D ) (R H D )
1 2 3 4
(BAT) (BAT) (IG) (BAT)
∗ 1 : w/ Wireless Door Lock Control
∗ 2 : w/o Wireless Door Lock Control
15A ∗ 3 : w/ Engine Immobiliser System 15A 7. 5A 10A
(D/L) ∗ 4 : Malysia (D/L) IG1/BACK HAZARD
2 2 2 2
2 2 2 2
B
B–W
R
(∗2)
(∗2)
(∗2)
Combination
Meter Assembly
< 26–4>
Transponder Key ECU
Assembly< 7–3>
E24 2
3 Door Control Relay 5 4
B LKSW ULSW
4
E57
Un–Lock Warning
Switch Assembly
1
(∗3)
L–B
R–W
E42
Junction
Connector
G
Combination Meter
Assembly< 26–2>
Turn Signal Flasher Assembly< 10–2>
Hazard Warning Signal
Switch Assembly< 10–2>
Transponder Key ECU
Assembly< 7–3>
Combination Meter
Assembly< 13–2>
1 9 8
2 E64
Junction
Connector
P
R
R
G
W
(∗1)
(∗1)
(∗4)
(∗3)
B–Y
P–B
L–W
W–R
LOK+ U/L+ E
2 1 25 21 12 17 11 4 23
2 1 6
LKM ULM B SPD IG CHR IMO CTY KYSW
P
P
V
G
G
E62
(∗2)
(∗2)
(∗2)
(∗1)
(∗1)
(∗2)
(∗2)
W–B
Door Control Receiver
G G G
UKS LKS E RMLP IND FSW HRN AIN AOUT
P P P
6 18 15 14 3 19 16 10 9
L
V
V
(∗1)
(∗4)
(∗4)
L–R
R–G
W–L
W–B
G–W
LG–R
(∗1)
P
P
G
G
9 BE3 5 JE3 4 JE3
8 JE1 3 JE1 17 FE1 8 FE1 14 FE1 12 FE1 34
B
AVANZA (EM19Y0E)
L
P
P
P
V
G
G
G
(∗4)
(∗4)
L–R
G–W
M OVERALL ELECTRICAL WIRING DIAGRAM
LG–R
HORN
Relay< 23–1>
P 4 5 2 6 2
Security
M E
E34
Combination Meter Assembly
B15
Engine Hood Switch
P
P
P
G
G
G
16 1
No. 1 Room Light Assembly< 13–3>
Lock
Unlock
G
BR
W–B
W–B
2 ML1 5 ML1
Option Connector
(Theft Warning ECU Assembly)
< 28–4>
13 FE1 10 BE3
P
P
P
P
G
G
G
G
2 1 2 1 2 1 2 1
W–B
W–B
W–B
G5 I4 H4 L4 E1 E4 E1 E4 E1 E2
Front Door Rear Door Rear Door Lock Back Door
Lock Assembly LH Lock Assembly LH Assembly RH Lock Assembly
20 AVANZA
P o w e r W in d o w (L H D )
1 2 3 4
(IG) G6
1 Power Window Regulator Master Switch Assembly
IG
30A
POWER
2
Window Lock Switch
2 Up Down
W–G
W–G
Up
Up
Up
18 GE2
Down
Down
Down
W–G
E M/U+ M/D+ PU+ PD+ RLU+ RLD+ RRU+ RRD+
6 10 11 2 5 7 3 12 4
W–G
W–G
P
R
G
W
LG
W–L
W–B
B–W
W–R
W–G
LG
W–L
G
W
B–W
W–R
W–G
W–G
AVANZA (EM19Y0E)
9 FE2 8 FE2 4 FE2 1 JE1 8 IJ1 7 IJ1 2 JE1 8 HJ1 7 HJ1
W–B
G
W
LG
LG
W–L
B–W
W–G
W–G
W–G
3 IJ1 3 HJ1
1 5 1 5 1 5
U+ D+ U+ D+ U+ D+
W–G
W–G
3 B 3 B 3 B
Up
Up
Up
Down
Down
Down
2 4 2 4 2 4
P
P
R
G
G
L–R
R–Y
R–Y
1 2 1 2 1 2 1 2
U+ D+ U+ D+ U+ D+ U+ D+
M M M M
E3 G3 F3 I2 H2
Front Power Window Regulator Front Power Window Regulator Rear Power Window Regulator Rear Power Window Regulator
Motor Assembly LH Motor Assembly RH Motor Assembly LH Motor Assembly RH
M
245
21 AVANZA
246
P o w e r W in d o w (R H D )
1 2 3 4
(IG) F4
1 Power Window Regulator Master Switch Assembly
IG
30A
POWER
2
Window Lock Switch
2 Up Down
W–G
W–G
Up
Up
Up
18 FE1
Down
Down
Down
W–G
E M/U+ M/D+ PU+ PD+ RLU+ RLD+ RRU+ RRD+
6 10 11 7 12 5 4 2 3
W–G
W–G
P
R
G
W
LG
W–L
W–B
B–W
W–R
W–G
LG
W–L
G
W
B–W
W–R
W–G
W–G
AVANZA (EM19Y0E)
9 GE1 8 GE1 4 GE1 1 JE1 8 IJ1 7 IJ1 2 JE1 8 HJ1 7 HJ1
M OVERALL ELECTRICAL WIRING DIAGRAM
W–B
G
W
LG
LG
W–L
B–W
W–G
W–G
W–G
3 IJ1 3 HJ1
1 5 1 5 1 5
U+ D+ U+ D+ U+ D+
W–G
W–G
3 B 3 B 3 B
Up
Up
Up
Down
Down
Down
2 4 2 4 2 4
P
P
R
G
G
L–R
R–Y
R–Y
1 2 1 2 1 2 1 2
U+ D+ U+ D+ U+ D+ U+ D+
M M M M
E3 F3 G3 I2 H2
Front Power Window Front Power Window Regulator Rear Power Window Regulator Rear Power Window Regulator
Regulator Motor Assembly RH Motor Assembly LH Motor Assembly LH Motor Assembly RH
22 AVANZA
F ro n t W ip e r a n d W a s h e r R e a r W ip e r a n d W a s h e r
1 2 3 4
(IG) (IG)
E30(A), (B)
20A Windshield Wiper Switch Assembly 15A
FR WIP (RR WIP)
Front Wiper Switch
2 WB +2 +1 +S INT1 INT2 B1 2
MIST
2 2
OFF Front Washer Switch W
G
INT EW W
G
G
W
LO Off
5 BE6 (LHD) 6 BE6 (LHD)
HI On
8 BE2 (RHD) 6 JE1 10 BE2 (RHD)
G
W
W
R–W
R–W
2
9 MJ1 8 MJ1 7 JE1
2 B7
B6 M Rear Washer
Windshield Washer Motor Assembly
M
Motor and
Pump Assembly 1
1
L
V
W
R–W
Wiper Relay
L
V
G
W
W–L
W–B
W–R
R–W
R–W
2 A 3 A (LHD)
2 1 9 B 8 B (RHD)
AVANZA (EM19Y0E)
+ – +1R WR
G
W–R
+1R WR EW
M
Washer
2 AE3 1 AE3 6 AE3 7 AE3 (LHD)
6 BE3 7 BE3 1 BE3 2 BE3 (RHD)
OFF
ON
G
L1
W–L
W–R
Rear Wiper and
Washer Switch
W–B
W–B
8 8
E39 E39
Junction Junction
A10(A), B8(B) Connector Connector
Windshield Wiper
Motor Assembly
E4 E4
M
247
23 AVANZA
248
C ig a re tte L ig h te r o r
H o rn P o w e r O u tle t R e a r W in d o w D e fo g g e r C o o lin g F a n
1 2 3 4
(BAT) (ACC) (IG) (BAT) (IG)
2 2 2 2 2
1 2 2 1 2
L
W
L–B
∗ 2 : w/o Steering Pad Switch
W–L
16 AE4
B
3 : w/ Steering Pad Switch
LG
∗
∗ 4 : w/ SRS E7
Rear Window Defogger
W
∗ 5 : w/o SRS
Door Control
Receiver< 18–4> < 19–4>
3 Switch Assembly
∗ 6 : w/ Theft Deterrent
∗ 7 : w/o Theft Deterrent B
1 1 2 1 1
+
V
(∗6)
2 3 3 2
E L E
E15
Cigarette Lighter Assembly or
Power Point Socket Assembly
3 10 HORN 1 4 5 RAD
Relay Relay
E64
Junction
Connector
P
11 1 5 5 1
11
3
W–B
W–B
1 1 E43 1 1
Junction
Connector
10
G
R–W
P
R–W
L
L
B
(∗6)
R–W
13 AE4 11 AE4 4 JE1
6 AE4
B
ECM
< 6–6>
12
AVANZA (EM19Y0E)
M OVERALL ELECTRICAL WIRING DIAGRAM
R–W
E43
Junction
Connector
R–W
2
6 MJ1 14
M
LG
LG
LG
LG
LG
(∗5)
B
(∗2 ∗4 ∗6)
(∗2 ∗4 ∗7)
(∗3 ∗4 ∗6)
(∗3 ∗4 ∗7)
11 BE3
A6
With Motor
Fan Assembly
1
4 ML1
ECM
< 6–6>
1 A 1 A
R–W
R–W
+ +
E54(A), z4(B)
Spiral Cable
Sub–Assembly
E32(A), z3(B)
Spiral Cable
Sub–Assembly
1 B 1 B 1 1 NL1
1 1
B
W–B
1 A
Horn
Switch
Horn
Switch
E31
Horn Button Assembly
A1
High Pitched Horn Assembly
B9
Low Pitched Horn Assembly
N1(A), O1(B)
Rear Window Defogger
BR
W–B
z4(B) z3(B) 1 B
Horn Button Assembly Steering Wheel 8 6
Sub–Assembly E39
B
Junction
Connector
E39
Junction
Connector
E4 O1 E4 A2
249 AVANZA (EM19Y0E)
24 AVANZA
5
16
BR
E4
E
E39
Junction Connector Buzzer
30
14
40
B–W B–W
1
8 AE4
(BAT)
+B
K e y R e m in d e r a n d L ig h t R e m in d e r
10A
BACK UP
2
9
2
2
39
R–L LG
2
(IG)
(M/T) (M/T)
IG
E48
Junction
10A
Connector
1
ECU IG2
Interior Light
CPU
LG
R–L
L
(A/T)
(A/T)
System< 13–2>
9
2
E43
Junction Connector
E34
2
1
W–B L–R
(RHD) (RHD)
J15
Front Seat Inner
Combination Meter Assembly
Belt Assembly RH
2
1
35
W–B L–R L–R
J1
5 JE2
(LHD) (LHD)
J10
DBLT
Front Seat Inner
3
Belt Assembly LH
Driver' s
Seat Belt
S e a t B e lt W a rn in g
4
M
25 AVANZA
250
∗ 1 : 4 Speaker
∗ 2 : 6 Speaker
∗ 3 : 2 Speaker
A u d io S y s te m ∗ 4 : w/ Steering Pad Switch
∗ 5 : w/ No. 1 Stereo Jack Adapter
1 2 3 4
(BAT) (ACC)
10A 10A
BACK UP ACC # : There is no wire color information.
2 2
z3(B)
1 2 Steering Wheel Sub–Assembly
B–W
L
(A/T)
5 B 3 B 4 B
2
8 AE4 EAU AU1 AU2 Antenna
E32(A), z3(B)
Spiral Cable
Sub–Assembly
L
(M/T)
5 A 3 A 4 A
E48
Junction
Connector
9
(∗4)
(∗4)
(∗4)
B–Y
B–W
(A/T)
R–W
W–G
W–G
E4(A), E5(B), E6(C), E53(D)
4 A 3 A Stereo Component Tuner Assembly 6 B 7 B 8 B
+B ACC EAU AU1 AU2
SPL+ SPL– SPR+ SPR– SRL+ SRL– SRR+ SRR– E ALI ARI ASGN AUXG UPO UDI– UDI+ UESG
2 A 6 A 1 A 5 A 2 C 6 C 1 C 3 C 7 A 17 B 15 B 18 B 16 B 1 D 2 D 3 D 4 D
LG
B–W
W–B
R–W
(∗1, ∗2)
(∗1, ∗2)
(∗1, ∗2)
(∗1, ∗2)
B
R
W
(∗5)
(∗5)
(∗5)
(∗5)
(Shielded)
R
W
(∗2)
(∗2)
(∗2)
(∗2)
B–W
R–W
2 4 6 13 2 EE1 1 EE1 3 EE1 5 EE1
#
#
#
#
(∗5)
(∗5)
(∗5)
(∗5)
R
W
B–W
R–W
E44
Junction
Connector
E44
Junction
Connector
(∗1, ∗3)
(∗1, ∗3)
(∗1, ∗3)
(∗1, ∗3)
AVANZA (EM19Y0E)
1 8 3 10 5 12 7 14
LG
B–W
R–W
M OVERALL ELECTRICAL WIRING DIAGRAM
(∗1, ∗2)
(∗1, ∗2)
(∗1, ∗2)
(∗1, ∗2)
V
R
W
LG
(∗2)
(∗2)
(∗2)
(∗2)
B
R
W
(∗5)
(∗5)
(∗5)
(∗5)
(Shielded)
E52
No. 1 Stereo Jack Adapter Assembly
L
R
G
W
(∗2)
(∗2)
(∗2)
(∗2)
B–W
B–W
B–W
B–W
B–W
R–W
R–W
R–W
R–W
R–W
(LHD)
(LHD)
(RHD)
(RHD)
(∗1, ∗2)
(∗1, ∗2)
(∗1, ∗2)
(∗1, ∗2)
2 1 2 1 2 1 2 1 2 1 2 1
E2 G1 E37 F1 I1 H1
No. 1 with Box Speaker Front No. 3 Speaker No. 1 with Box Speaker Front No. 3 Speaker Rear Stereo Rear Stereo
Assembly LH Assembly LH Assembly RH Assembly RH Component Speaker Component Speaker
W–B
Assembly LH Assembly RH
E1
Memo
11
W–B W–G LG
2
IG
E4
(IG)
GND
Junction
10A
Connector
1
Junction
Connector
OUT
ECU IG2
26 AVANZA
E50
Speedometer Sensor
1
1
L–W
Interior Light
(M/T ∗3)
System< 13–2>
21
Door
CTY
(∗5) (∗5)
(∗6) (∗6)
2
40
B–W B–W
1
8 AE4
(BAT)
+B
12
SPDI
BACK UP
17 BE4
39
R–L LG
(M/T) (M/T)
IG
13
Receiver
< 19–3>
E40(A), E41(B) E43
Junction Junction
2
Connector Connector
Power Steering W–L
Tachometer
DLC3 G–R
P1
T
Gauge
3
2
2
19
2 PJ1
9 JE2
(IG)
–
+
+
(A/T)
10A
ECU IG2
BR BR
R+
J2
1 PJ1
22
P
C o m b in a tio n M e te r
3
20
L L
5 CE1
+
23
C15
N
Engine Coolant
Temperature Sensor
26
Brake Actuator B B
< 6–15> < 6–16>
1 BE4
2
2
1
8
27
W–B B B
CPU
–
+
A1
12 AE3
–
L
ECT and A/T Indicator System
E1
D
(LHD ∗3)
3
4
3
2
1
2
1
W–B B B
–
+
10 BE3
7 BE3
(LHD) (LHD)
E34
(LHD ∗1)
: w/ ABS
B13
: w/o ABS
1 A
10 B
2 BE4
Assembly (∗1) (∗1)
: w/ Multi Information Display
: w/o Multi Information Display
< 14–3>
2 A
E40(A), E41(B) E40(A), E41(B)
(∗1)
W–R
Junction Connector Junction
Connector
1
9
10
W–R W–R R–B V–R ECM
6 B
5 A
14 JE2
(∗3) < 6–6>
PKB
REV
J5
28
Parking Brake Switch
4
5 B
7 A
Multiplex Communication < 8–3>
∗ 7 : Malaysia
CANH
System (CAN)< 2–3>
CAN IC
29
Option
R–Y Connector
(∗4) (Theft
6 A
(∗7) Warning
CANL
∗ 5 : w/ Door Indicator Light
ECU Assembly)
∗ 6 : w/o Door Indicator Light
< 28–3>
35
Seat Belt Warning
System< 24–2> B–Y Power Steering
ECU Assembly
DBLT
< 16–2>
30
Key Reminder and
Light Reminder System
< 24–1>
KEY
(Cont. next page)
M OVERALL ELECTRICAL WIRING DIAGRAM
253 AVANZA (EM19Y0E)
Clock
ODO/TRIP (∗2)
ODO/TRIP DISP(∗4)
CPU
(∗4)
5
26 AVANZA (Cont' d)
5
16
BR
E4
E
E39
Junction Connector Buzzer
Driver' s
Seat Belt
Brake
E34
18
ABS System
–
< 14–4>
ABS
6
(∗4)
Combination Meter Assembly
AT
(∗4) (∗4)
31
Temperature Hot
Security
34
Charging System
< 4–3>
CHG
17
SRS System
< 15–4>
C o m b in a tio n M e te r
A/B
SRS
High Beam
2
Headlight System
+
< 9–2>
Turn LH
7
5
+
Back Sonar
32
Option Connector
(Parking Assist)
< 28–1>
LD+
Power Steering
15
EPS System
< 16–4>
EPSW
Oil
1
38
R R
6 CE1
–
C17
Engine Oil Pressure Switch Assembly
Check Engine
37
Engine Control System
< 6–16>
EFI
Pointer Illumination
8
14
Illumination and
Taillight System
< 12–1>
ILM+
∗ 4 : w/ Multi Information Display
∗ 2 : w/o Multi Information Display
LCD
Illumination
M
27 AVANZA
254
∗ 1 : w/ Heater
A ir C o n d itio n e r ∗ 2 : w/o Heater
∗ 3 : w/ Rear A/C
1 2 3 4
P
(∗1)
2
40A 10A 10A 7. 5A 2
HTR (A/C NO. 2) (A/C NO. 1) IG1/BACK
+B
7. 5A
(HTR SUB)
2 2 2 2
1 1 2 1 2
V
V
G
B–W
L
(∗1)
3 4 – –
E65
Cooler Switch
5 AE2
(∗3)
4 3
R–W
R–W
17 AE4
E42
Junction
Connector
L
(∗1)
10
G
8 KE1
2
(∗2)
LG–R
G
E16
M Blower Motor LG–R
(Cooler Unit
Assembly) 2 2 1 1 (∗1)
1
(∗3)
R–W
K3
L
L
W
Rear Cooling 1 BE6 (LHD)
(∗2)
(∗1)
5 2 Unit Assembly 2 3 2 5 BE2 (RHD)
+
4
W
HTR (MGC)
Relay Relay
LG–R
4
Blower Motor M 1
+ 3 1 5 1
(∗2)
(∗2)
L–Y
L–Y
R–Y
GR
(∗1)
R–Y
Hi 2
2 2 2 1 1
–
M2 M&M1 L 2 1 B 2 B
E17
Blower Resistor
(Cooler Unit Assembly)
L–R
2 3 1 G–W
V
Blower Me
Switch
Liquid Pipe)
B5
No. 1 Pressure Switch
(Cooler Refrigerant
W–B
2
E40(A), E41(B)
Junction Connector
L
10 AE4 7 AE4 10 A
E11
Cooler Thermistor
(Cooler Unit Assembly)
W
A/C Volume Switch
3
1
L–Y
R–W 10 +
AVANZA (EM19Y0E)
E13
Heater Control Assembly
OFF
M OVERALL ELECTRICAL WIRING DIAGRAM
E48
Junction
Connector
L–R
G–W
11 4
4 5 6 8 E 3 BE6 (LHD)
H M2 M, M1 L 1 6 BE2 (RHD)
(∗3)
L–R
B–Y
7 CE1
H M2 M, M1 L E (∗3)
(∗2)
L–Y
L–R
B–Y
B–Y
R–G
W–R
OFF
W–B
29 C 14 C 30 C 31 C
1 1
3 KE1 ACSW ACEV ACVR E21
2 +
Blower Switch
3
(∗3)
B–Y
15 C 11 C E3(C) 16 C
4
ECM
L–R
E
G–W
E14 1
Heater Control Assembly
4 1
W–B
E39
Junction
Connector
E39
Junction Connector
Engine Control
System< 6–6>
E2 E4 E4
28 AVANZA
O p tio n C o n n e c to r (P a rk in g A s s is t) O p tio n C o n n e c to r (T V S S )
1 2 3 4
(IG) (BAT)
10A 15A
ECU IG2 (D/L)
2 2
2 2
∗ 1 : Malaysia, Thailand w/ Steering Pad Switch
∗ 2 : Malaysia
LG
LG
(A/T ∗1)
(M/T ∗1)
2 2
E48
Junction
Connector
E43
Junction
Connector
9 9
R–L
R–L
(A/T ∗1)
(M/T ∗1)
Q1 Q2
Option Connector Option Connector K5
(No. 1 Ultrasonic (No. 1 Ultrasonic Option Connector
39 Sensor LH) Sensor RH) (Room Light Assembly No. 2)
IG
L
L
B
B
V
P
B
R
R
R
Back Sonar
(∗1)
(∗1)
(∗1)
(∗1)
(∗2)
(∗2)
(∗2)
(∗2)
(∗2)
(∗2)
(∗2)
LG–B
Combination Meter
Assembly< 26–4>
E34
Combination
Meter Assembly
32
L
B
V
P
(∗1)
(∗1)
(∗2)
(∗2)
(∗2)
(∗2)
(∗2)
R–Y
G–Y
LG–B
Door Control
Receiver< 19–4>
AVANZA (EM19Y0E)
6 JE2 3 QJ1 1 QJ1 4 QJ1 7 JE3 6 JE3 11 JE3 13 JE3 12 JE3 14 JE3
Combination Meter
Assembly< 13–4>
STOP Fuse< 13–4>
L
L
B
V
P
R
R
(∗1)
(∗1)
(∗1)
(∗1)
(∗2)
(∗2)
(∗2)
(∗2)
(∗2)
(∗2)
(∗2)
(∗2)
R–Y
G–Y
G–W
LG–B
LG–R
11 8 15 16 3 7 2 8 9 5 4 10
LD T1 TE T2 +B ROUT RIN REV RSIG SGND SSIG SPW
EE IG GND
14 J11 7 1 J12
Option Connector Option Connector
(Rear Clearance Warning ECU Assembly) (Theft Warning ECU Assembly)
(∗1)
(∗1)
(∗2)
W–B
V–W
W–B
Back–Up Light
Switch Assembly
< 11–1>
Park/Neutral
Position Switch
Assembly< 11–1>
J1 J1
M
255