BT50 - Uny0 4 PDF

WARNING
Servicing a vehicle can be dangerous. If you have not received

service-related training, the risks of injury, property damage, and
failure of servicing increase. The recommended servicing
procedures for the vehicle in this workshop manual were
developed with Mazda-trained technicians in mind. This manual
may be useful to non-Mazda trained technicians, but a technician
with our service-related training and experience will be at less
risk when performing service operations. However, all users of
this manual are excepted at least to know general safety
procedures.
This manual contains “Warnings” and “Cautions” applicable to

risks not normally encountered in a general technician’s
experience. They should be followed to reduce the risk of injury
and the risk that improper service or repair may damage the
vehicle or render it unsafe. It is also important to understand that
the “Warnings” and “Cautions” are not exhaustive. It is
impossible to warn of all the hazardous consequences that might
result from failure to follow the procedures.
The procedures recommended and described in this manual are

effective methods of performing service and repair. Some require
tools specifically designed for a specific purpose. Persons using
procedures and tools which are not recommended by Mazda
Motor Corporation must satisfy themselves thoroughly that
neither personal safety nor safety of the vehicle will be
jeopardized.
The contents of this manual, including drawings and

specifications, are the latest available at the time of printing, and
Mazda Motor Corporation reserves the right to change the vehicle
designs and alter the contents of this manual without notice and
without incurring obligation.
Parts should be replaced with genuine Mazda replacement parts

or with parts which match the quality of genuine Mazda
replacement parts. Persons using replacement parts of lesser
quality than that of genuine Mazda replacement parts must
satisfy themselves thoroughly that neither personal safety nor
safety of the vehicle will be jeopardized.
Mazda Motor Corporation is not responsible for any problems

which may arise from the use of this manual. The cause of such
problems includes but is not limited to insufficient service-
related training, use of improper tools, use of replacement parts
of lesser quality than that of genuine Mazda replacement parts, or
not being aware of any revision of this manual.
Form No. 5753-1A-08E

Form No. 5753-10-08F
Mazda CONTENTS
TITLE SECTION
BT-50
Wiring Diagram GENERAL INFORMATION 00
ENGINE 01
FOREWORD
This wiring diagram incorporates the wiring schematics SUSPENSION 02
of the Mazda BT-50 and available optional equipment.
Actual vehicle wiring may vary slightly depending on
optional equipment or local specifications, or both. DRIVELINE/AXLE 03
For proper repair and maintenance, a thorough

familiarization with this manual is important, and it BRAKES 04
should always be kept in a handy place for quick and
easy reference.
TRANSMISSION/TRANSAXLE 05
All the contents of this manual, including drawings and
specifications, are the latest available at the time of
printing.
As modifications affecting repair or maintenance occur, STEERING 06
relevant information supplementary to this volume will be
made available at Mazda dealers. This manual should
HEATER, VENTILATION & AIR
be kept up-to-date. 07
CONDITIONING (HVAC)
Mazda Motor Corporation reserves the right to alter the
specifications and contents of this manual without RESTRAINTS 08
obligation or advance notice.
All rights reserved. No part of this book may be

reproduced or used in any form or by any means,
BODY & ACCESSORIES 09
electronic or mechanical-including photocopying and
recording and the use of any kind of information storage
and retrieval system-without permission in writing. ALPHABETICAL INDEX AI
© 2008 Mazda Motor Corporation

Mazda Motor Corporation
HIROSHIMA, JAPAN PRINTED IN AUSTRALIA, MAY 2008
5753-1A-08E
APPLICATION:
This manual is applicable to vehicles beginning with
the Vehicle Identification Numbers (VIN) shown on
the following page.

Form No. 5753-10-08F
J97SLG1E_GI.fm 2 ページ２００８年８月２７日　水曜日　午後３時４７分
Mazda BT-50 Wiring Diagram (5753-10-08F) (5753-1A-08E)
VEHICLE IDENTIFICATION NUMBERS (VIN)

(CHASSIS NUMBERS)
Australian specs.
MM0 UNY0E400 800001-
MM0 UNY0W400 800001-
General (R.H.D.) specs.
MM6 UNY064*0 800001-
MM6 UNY0E4*0 800001-
MM6 UNY0W4*0 800001-
Revised 9/2008 (Ref. No. L081/08)

Form No. 5753-10-08F
SYSTEM INDEX
00 GENERAL INFORMATION 08 RESTRAINTS

R READING WIRING DIAGRAMS 10 AIR BAG SYSTEM
VEHICLE IDENTIFICATION NUMBER (VIN) CODE.......2 AIR BAG SYSTEM (INCLUDES PRE-TENSIONER
VEHICLE IDENTIFICATION NUMBERS (VIN)................3 SEAT BELT INFORMATION) ...................................... 88
CONTENTS OF WIRING DIAGRAMS ............................4 09 BODY & ACCESSORIES
GROUND POINTS ..........................................................5
SYSTEM CIRCUIT DIAGRAM/CONNECTOR DIAGRAM ...6 12 GLASS/WINDOWS/MIRRORS
ROUTING DIAGRAM ......................................................8 REAR WINDOW DEFROSTER ................................... 92
HARNESS SYMBOLS.....................................................9 POWER WINDOW SYSTEM ........................................ 94
WIRING COLOR CODE ..................................................9 POWER OUTER MIRROR ........................................... 98
SYMBOLS .....................................................................10 14 SECURITY AND LOCKS
SERVICE WARNING AND CAUTION FOR VEHICLES POWER DOOR LOCK SYSTEM ................................ 100
KEYLESS CONTROL MODULE................................. 104
WITH SRS AIR BAG SYSTEM...................................12
IMMOBILIZER SYSTEM............................................. 106
SERVICE WARNING FOR VEHICLES THEFT-DETERRENT SYSTEM .................................. 108
WITH DISCHARGE HEADLIGHT ..............................12 18 LIGHTING SYSTEMS
ABBREVIATIONS USED IN THIS MANUAL .................12 HEADLIGHT ............................................................... 112
P ELECTRICAL SYSTEM GENERAL PROCEDURES......14 LICENSE PLATE LIGHT ............................................. 114
POWER, GROUND & COMMON CONNECTOR PARKING LIGHT......................................................... 114
TAILLIGHT .................................................................. 114
E ELECTRICAL WIRING SCHEMATIC ...........................18 FRONT FOG LIGHT ................................................... 116
F FUSE BOX ....................................................................20 TURN AND HAZARD WARNING LIGHT.................... 118
C COMMON CONNECTOR LIST .....................................22 BACK-UP LIGHT ........................................................ 120
G GROUND POINT...........................................................28 BRAKE LIGHT ............................................................ 122
DATA LINK CONNECTOR HIGH-MOUNT BRAKE LIGHT.................................... 122
D DATA LINK CONNECTOR ............................................32 ILLUMINATION LIGHT................................................ 124
INTERIOR LIGHT ....................................................... 128
01 ENGINE 19 WIPER/WASHER SYSTEM
14 FUEL SYSTEM .............................................................36 WINDSHIELD WIPER AND WASHER ....................... 130
17 CHARGING SYSTEM ...................................................38 20 ENTERTAINMENT
19 STARTING SYSTEM.....................................................40 ACCESSORY SOCKET.............................................. 132
40 CONTROL SYSTEM CIGARETTE LIGHTER............................................... 132
WL-C, WE-C ...............................................................42 AUDIO SYSTEM ......................................................... 134
WLT WITHOUT IMMOBILIZER SYSTEM ..................52 22 INSTRUMENTATION/DRIVER INFO.
WLT WITH IMMOBILIZER SYSTEM ..........................56 INSTRUMENT CLUSTER........................................... 138
G6...............................................................................60 HORN ......................................................................... 148
03 DRIVELINE/AXLE AI ALPHABETICAL INDEX
18 4-WHEEL DRIVE ALPHABETICAL INDEX ............................................. 150
REMOTE FREEWHEEL CONTROL SYSTEM
WL-C, WE-C ...............................................................66
WLT ............................................................................70
4X4 CONTROL SYSTEM ..............................................72
04 BRAKES
13 ANTILOCK BRAKE SYSTEM
4-WHEEL ANTILOCK BRAKE SYSTEM (4W-ABS)......76
05 TRANSMISSION/TRANSAXLE
13 AUTOMATIC TRANSMISSION
AUTOMATIC TRANSMISSION CONTROL SYSTEM ...78
07 HEATER, VENTILATION & AIR CONDITIONING
(HVAC)
40 CONTROL SYSTEM
HEATER AND AIR CONDITIONER...............................86
Two digits (section ID) indicated in front of each title are commonly used with the Workshop Manual.

Form No. 5753-10-08F
00R Reading Wiring Diagrams
VEHICLE IDENTIFICATION NUMBER (VIN) CODE
MM0 UN Y0 W 4 9 0 123456
Serial No.
No meaning 0
for General (L.H.D. R.H.D.) Model year 9= 2009 A=2010, B=2011...
for Australia No meaning 0
Minor change code 4
2= F2 (2.2L)
6= G6 (2.6L)
W= WL-C, WLT-1, WLT-2 (2.5 L)
Engine type E= WE-C (3.0L)
Body style Y0= Long
Carline, Series UN= Mazda BT-50
MM0= MAZDA (Australia)

MM6= MAZDA (General (R.H.D.))
World manufacturer identification MM7= MAZDA (General (L.H.D.))

Form No. 5753-10-08F
J97SLG1E_GI.fm 3 ページ２００８年８月２７日　水曜日　午後３時４７分

Reading Wiring Diagrams 00R
VEHICLE IDENTIFICATION NUMBERS (VIN)
Australian specs.
MM0 UNY0E400 800001-
MM0 UNY0W400 800001-
General (R.H.D.) specs.
MM6 UNY064*0 800001-
MM6 UNY0E4*0 800001-
MM6 UNY0W4*0 800001-
3 Revised 9/2008 (Ref. No. L081/08)

Form No. 5753-10-08F
CONTENTS OF WIRING DIAGRAMS
• This manual comprises the sections shown below.
R Reading wiring diagrams

A how-to on using and reading wiring diagrams, using test
equipment, checking harness and connectors, and finding
trouble spots
P Electrical
system general
procedures
E Electrical wiring schematic Shows main fuses and other fuses for each system
GENERAL
INFORMATION 00 F Fuse box complete wiring
system
Shows internal circuits and connectors
J Joint
box/Junction box
complete wiring system
C Common connector list Shows connectors common throughout system
G Ground point Ground routes from and to the battery
D Data link connector
12 Cooling system
14 Fuel system
17 Charging system
ENGINE 01 18 Ignition system
19 Starting system
20 Cruise control system
40 Control system
SUSPENSION 02 12 Wheel and tires
DRIVELINE/AXLE 03 18 4-Wheel drive
13 Antilock brake system
BRAKES 04 14 Traction control system
15 Dynamic stability control
13 Automatic transmission
Automatic transmission shift
14 mechanism
TRANSMISSION/
TRANSAXLE 05
17 Automatic transaxle
18 Automatic
transaxle shift
mechanism Shows circuit and connector diagrams and component and
13 Electric power steering (EPS) connector location diagrams
STEERING 06
14 Power steering
HEATER,
VENTILATION &
AIR 07 40 Control system
CONDITIONING
(HVAC)
10 Air bag system
RESTRAINTS 08
11 Seat belt
12 Glass/Windows/Mirrors
13 Seats
14 Security and locks
15 Sunroof
16 Exterior trim
BODY &
ACCESSORIES 09 18 Lighting systems
19 Wiper/Washer system
20 Entertainment
21 Power systems
22 Instrumentation/Driver info.
40 Control system
AI Alphabetical Index Gives page number of circuit diagram for each component
Depending on the vehicle model, the actual sections may be different.

Form No. 5753-10-08F
GROUND POINTS
• This shows ground points of the harness.
GROUND POINTS (4SD)
3 8 G-01 JOINT CONNECTOR(F) G-02 JOINT CONNECTOR(F) G-03 JOINT CONNECTOR(D)
D C B A
D B D B E
4 9 B B E C A E C A
B 3 B/O 4 6 B B B B B
B B B B B B B B B B B
5 10 B B/W B B B B
7 12 E D C B A
E D C B A E D C B A
(WITHOUT AIR BAG SYSTEM)
D C B A
E
B B B B B
B B
E D C B A
(WITH AIR BAG SYSTEM)
WITH ABS
B(D) 10
B(EM) 4 G-03
B(D) B(D)
G-01 B(EM)
B(F) B(D)
B(EM) 4 EMISSION
B(F) HARNESS B(D) 11
B(EM) 5 (EM)
B(F) 1 B(D)
B(F) B(EM) 5 B(D)

DASH
B(F) B(D) HARNESS
B(EM) 6 (D)
TO
EACH B/W(EM) B(D)
UNIT TO
B WITH AIR BAG SYSTEM
EACH
TO (F) FRONT UNIT B(D)
EACH HARNESS 3
G-02
UNIT (F)
B/O(D) 3
B(F)
WITHOUT AIR BAG SYSTEM
B(F) B(I) 8
B(F) 2
INSTRUMENT
B(F) B(I) 9 PANEL INTERIOR
HARNESS B(IN) LIGHT
(I) 7
B(F) HARNESS
B(I) (IN)
B(F) 9
SHORT
B(F) B 12 CORD
Ground indication
On vehide Indication
On circuit diagrams and ground points
The ground connection numbers in system circuit diagrams

correspond to those in the ground point diagram.
To circuit
CONTROL SYSTEM
BATTERY MAIN IG KEY
- + F-09 100A 60A F-07 D C-01
B(E) B/W(F) B/W(D)
B
A F-05
BTN B(F) B(D)
INJ OR 40A G J-05 J-03
FIP W/R(F) W/R(D)
30A A ROOM 1B
A J C-03
10A
8
L/R OFF
F-03 (D) ENGINE SWITCH ST
F-03 F-04
W/G(EM) Y/L(F) ENGINE IG1 IG2 ACC
T S F-04 G C-06 J-04 10A 14 J-01 C-03

I
B/L(D) L(D)
MAIN RELAY
F-03 2 C-06 AA F H
D U
SPV RELAY
F-04 Y C-09 LG/R W/Y (SECTION 0140-1b) L/R B/L
L/R(E) L/R(EM) (EM) (EM) (EM) (EM)
B/W 0140-101
(F)
3W 1E 1B 1A 1F
0140-103 0140-102
PCM
GLOW 2M 3R 3P 1S 1N 1Q
PLUG
RELAY 0140-101
L
0140-102 (EM)
L
(E) L/B
F-01 F-03 LG BR/B G/B G/W
L(E) (EM) (EM) (EM) (EM)
(EM)
I V
L B
(E) (E)
0140-105 J C-09
11
23 22 14 31
B A/C RELAY
REFRIGERANT AD FAN RELAY (SECTION 0740-2)
B DATA LINK CONNECTOR(DLC) PRESSURE SWITCH (SECTION 0740-2)
0140-104 (SECTION 00D)
(EM) (SECTION 0740-1)
GLOW
PLUG
0140-101 1U 1O 1M 1K 1I 1G 1C 1A 2O 2K 2I 2G 2E 2A 3Y 3U 3Q 3O 3M 3K 3I 3A 0140-102
PCM(EM) 1S 1Q 1E 2M 2C 3W 3S 3G 3E 3C GLOW PLUG RELAY(E)
Y W/R L/B P/L L/W L/R LG/R R/Y L/R G/R L LG/B BR/W R/L R/Y GY/R P/B B/W L/R R/B V R B G/Y
L/R
LG BR/B Y/B G/R G W L L
W/G W/L V/W G/W B/L V W/Y R L/W BR/Y L/Y O R/L B/O
B
1V 1T 1R 1P 1N 1L 1J 1H 1F 1D 1B 2P 2N 2L 2J 2H 2F 2D 2B 3Z 3X 3V 3T 3R 3P 3N 3L 3J 3H 3F 3D 3B
0140-103 0140-104 0140-105
GLOW PLUG RELAY(F) GLOW PLUG(SHORT CORD) ENGINE(E)-SHORT CORD
(E) (SHORT CORD)
B/W B
L B

Form No. 5753-10-08F
SYSTEM CIRCUIT DIAGRAM/CONNECTOR DIAGRAM
• These diagrams show the circuits for each system, from the power supply to the ground. The power supply side
is on the upper part of the page, the ground side on the lower part. The diagrams describe circuits with the
ignition switch off.
Below is an explanation of the various points in the diagram.
CONTROL SYSTEM
BATTERY MAIN IG KEY
System name - +
B(E)
F-09 100A 60A F-07 D
B/W(F)
C-01
B
A F-05
B(F)
INJ OR G
FIP
30A
F-03 F-03 F-04

W/G(EM) Y/L(F)
GLOW I T S F-04 G
40A MAIN RELAY
F-03
D U
C-09
F-04 Y LG/R W/Y
L/R(E) L/R(EM) (EM) (EM)
B/W 0140-101
(F)
3W 1E 1B
0140-103 0140-102
GLOW 2M 3R 3P
PLUG
RELAY 0140-101
L
Connector code 0140-102 (EM)
F-01 F-03 LG BR/B

The prefix letter indicates the system in which the B
(E)
L(E) (EM) (EM)
I V
connector is used. L
(E)
C-09 J 0140-105
F: Fuse box connectors B 23 22
J: Joint box/Junction box connectors B

0140-104
DATA LINK CONNECTOR(DLC)
(EM) (SECTION 00D)
C: Common connectors
GLOW
G: Ground point connectors PLUG
D: Data link connector 5

0112: Cooling system connectors
0140-101 1U 1O 1M 1K 1I 1G 1C 1A
0114: Fuel system connectors PCM(EM) 1S 1Q 1E
2O
2M
2K 2I 2G 2E
2C
2A
0117: Charging system connectors Y W/R L/B P/L L/W L/R W/Y LG/R R/Y R/W G/R L LG/B BR/W R/L R/Y GY/R P/B
W/G W/L V/W G/W B/L G/Y W/Y R L/W BR/Y L/Y O
0118: Ignition system connectors 1V 1T 1R 1P 1N 1L 1J 1H 1F 1D 1B 2P 2N 2L 2J 2H 2F 2D 2B
0119: Starting system connectors 0140-103

GLOW PLUG RELAY(F)
0140-104
GLOW PLUG(SHORT CORD)
0140-105
ENGINE(E)-SHORT CORD
0120: Cruise control system connectors B
(E) (SHORT CORD)
B/W
0140: Engine control system connectors L B
0212: Wheel and tires connectors

0318: 4-Wheel drive connectors
0413: Antilock brake system connectors
0414: Traction control system connectors
0415: Dynamic stability control connectors
0513: Automatic transmission connectors
0514: Automatic transmission shift mechanism Ground numbers
connectors
0517: Automatic transaxle connectors A harness ground is represented differently than a
0518: Automatic transaxle shift mechanism unit ground.
connectors
0613: Electric power steering (EPS) connectors
0614: Power steering connectors Types of grounds Symbol
0740: Heater, ventilation & air conditioning (HVAC) Harness
control system connectors
0810: Air bag system connectors
0811: Seat belt connectors
0912: Glass/Windows/Mirrors connectors
9
0913: Seats connectors
0914: Security and locks connectors
0915: Sunroof connectors Unit
0916: Exterior trim
0918: Lighting systems connectors
0919: Wiper/Washer system connectors
0920: Entertainment connectors
0921: Power systems
Sensor
0922: Instrumentation/Driver info. Connectors
0940: Control system

Form No. 5753-10-08F
The number indicates that the circuit
continues to the related system
diagram. System code
Multiplex communication
0140-1a Indicates communication with connected parts.
Signals are transmitted back and forth between
DATA LINK
B/W(D) CONNECTOR(DLC)
(SECTION 00D)
connected parts.
B(D)
16 A B
1B
C-03
OFF
ENGINE SWITCH ST
ENGINE IG1 IG2 ACC
C-06 J-04 10A 14 J-01 C-03
G/Y
(EM)
W/Y
(EM)
R/W
(EM) Current symbol
B/L(D) L(D)
AA F H
B/L
(EM)
Current flows in the direction of the arrow.
0140-101
1F 1D 1I 1A
PCM
1S 2A 2C 2B 2E Indicates shielded wire.*
SHIELD WIRE
R/Y
(EM) * Shielded wire :
W/R
0140-107
INTAKE AIR
Prevents signal disturbances from
(EM) TEMPERATURE
SENSOR NO.1
electrical interference.
P/B
(EM)
GY/R
(EM)
O
(EM)
0140-107
O
Wire is covered by a metal meshing for
(EM)
grounding.
14 B
(EM)
REFRIGERANT
PRESSURE SWITCH
(SECTION 0740-1) 0140-106 Connector symbols
BOOST SENSOR • Male and female connectors are represented as follows

4 in the circuit and connector diagrams.
3Y 3U 3Q 3O 3M 3K 3I 3A 0140-102
3W 3S 3G 3E 3C GLOW PLUG RELAY(E) Circuit diagram Connector
B/W L/R R/B V R B G/Y
L/R
symbol diagram symbol
R/L LG BR/B Y/B G/R G W L B/O L
B
3Z 3X 3V 3T 3R 3P 3N 3L 3J 3H 3F 3D 3B
0140-106 0140-107
BOOST SENSOR(EM) INTAKE AIR TEMPERATURE SENSOR NO.1(EM) L
Male
P/B GY/R O O R/Y Male R
Female
L
Female
R
Wire color code (harness symbol) • Like connectors are linked by dashed lines between the
• Two-color wires are indicated by a two-letter connector symbols.
symbol.The first indicates the base color of the • Connector diagrams show connectors on the harness
wire, the second the color of the stripe. side. The terminal indicates the view from the harness
For example: side.
W/R is a white wire with a red strip
(Example)
BR/Y is a brown wire with a yellow strip
Symbol Connector on harness side
(Example)
Solid color wire Striped wire
White
(base color) View from harness side
B Black W/R
(F) (F)
Red(stripe)
• The harness symbol is in ( ) following the harness • Colors for connectors except white are given in locations.
symbols (refer to P-9.). • Unused terminals are indicated by ∗.

Form No. 5753-10-08F
ROUTING DIAGRAM
• The routing diagram shows where electrical components are on the system circuit diagram by call out line and
connector symbols.
Connector symbol Component name Ground symbol

Shows the system that uses the Shows the names of components Shows the ground in system
connector.
in routing diagrams. diagrams.
(Example)
Connector Symbol
Common connectors C-02
System connectors 0922-05
HARNESS SYMBOL : (F) (E) (R)
INSTRUMENT CLUSTER
VACUUM SWITCH
0922-01
0922-05
(F)-(I) 6
C-02
(F)-(I)
C-02
0922-06
PARKING BRAKE SWITCH

Form No. 5753-10-08F
HARNESS SYMBOLS
DESCRIPTION OF HARNESS SYMBOL DESCRIPTION OF HARNESS SYMBOL

FRONT HARNESS (F) DOOR No. 1 HARNESS (DR1)
FRONT No. 2 HARNESS (F2) DOOR No. 2 HARNESS (DR2)
—
ENGINE HARNESS (E) DOOR No. 3 HARNESS (DR3)
DASH HARNESS (D) DOOR No. 4 HARNESS (DR4)
REAR HARNESS (R) FLOOR HARNESS (FR) —
REAR No. 2 HARNESS (R2) INTERIOR LIGHT HARNESS (IN) —
REAR No. 3 HARNESS (R3) A/C HARNESS (AC) —
INSTRUMENT PANEL HARNESS (I) — INJECTION HARNESS (INJ) —
EMISSION HARNESS (EM) HAND BRAKE HARNESS (HB) —
EMISSION No. 2 HARNESS (EM2) —
EMISSION No. 3 HARNESS (EM3)
WIRING COLOR CODE
COLOR CODE COLOR CODE

BLACK B ORANGE O
BLUE L PINK P
BROWN BR RED R
DARK BLUE DL SKY BLUE SB
DARK GREEN DG TAN T
GRAY GY VIOLET V
GREEN G WHITE W
LIGHT BLUE LB YELLOW Y
LIGHT GREEN LG

Form No. 5753-10-08F
SYMBOLS
Symbol Meaning Symbol Meaning

Battery • Generates electricity through chemical Light • Emits light and generates heat when
reaction. current flows through filament.
• Supplies direct current to circuits.
3.4W
Ground (1) • Connecting point to vehicle body or –––––––––––––––
other ground wire where current flows

from positive to negative terminal of
battery.
1 • Ground (1) indicates a ground point to
body through wire harness.
Ground (2) • Ground (2) indicates point where Resistance • A resistor with a constant value.
component is grounded directly to • Mainly used to protect electrical
body. components in circuits by maintaining
rated voltage.
Remarks
• Current will not flow through a circuit if
Ground (3) ground is faulty. Motor • Converts electrical energy into
mechanical energy.
Fuse • Melts when current flow exceeds that Pump • Pulls in and discharges gases and
specified for circuit, interrupts current liquids.
flow.
Precautions
• Do not replace with fuses exceeding
specified capacity. Cigarette lighter • Electrical coil that generates heat.
<Blade type> <Tube type>
Fuse (For high Accessory socket • Interior power supply.

current fuse)/
Fusible link
<Cartridge type> <Fusible link>
Horn • Generates sound when current flows.
Speaker
Transistor (1) • Electrical switching component.

• Turns on when voltage is applied to
the base (B).
Collector (C)
Collector
Heater • Generates heat when current flows.
indication
Base (B) NPN mark C
B E
Emitter (E) EC B
E C
B
Transistor (2) • Reading code. Ignition switch • Turning ignition key switches circuit to
Collector (C)
operate various component.
2 S C 828 A Revision mark (NOTE)
B2 B1
A:High-frequency PNP ST Ignition switch is called engine switch
Base (B) PNP Semiconductor B:Low-frequency PNP OFF OFF on diesel vehicles.
Number of C:High-frequency NPN IG2
IG1 ACC
terminals D:Low-frequency NPN
Emitter (E)
10

Form No. 5753-10-08F
Symbol Meaning Symbol Meaning
Switch (1) • Allows or breaks current flow by Harness
D
opening and closing curcuits. Connection A B
When circuit C-D

is connected to
Normally open circuit A-B, the
C
connection D is
Switch (2) indicated by a For vehicles with ABS, use the A-B
black dot. circuit.
Selection WITH ABS
A
Normally closed
Diversion point D
D
Autostop switch • Automatically shuts off circuit when for the different B
certain conditions are met. circuits according
to the vehicle’s WITHOUT ABS
specification is C
indicated by a
white dot. For vehicles without ABS, use the C-B
circuit.
Relay (1) • Current flowing through coil produces electromagnetic force causing contact to open or close.
No current to coil Current to coil
No flow Flow
Normally open
Relay (2) • Current flowing through coil produces electromagnetic force causing contact to close.
No current to coil Current to coil
Flow No flow
Normally closed
Sensor (1) • Detects characteristics such as intake Solenoid • Current flowing through coil generates
manifold vacuum and airflow amount electromagnetic force to operate
according to resistance variation. plungers.
Sensor (2) • Detects resistance variation according Diode • Known as a semiconductor rectifier,
to operation of other parts. the diode allows current flow in one
direction only.
Cathode(K) Anode(A)
Sensor (3) • A resistor whose resistance variation Flow of electric current
according to temperature variation.
• When temperature increases, K A K A K A
resistance decreases.
Sensor (4) • Detects pulse signals from rotating Light-emitting • A diode that lights when current flows.
object. diode • Unlike ordinary bulbs, the diode does
(LED) not generate heat when lit.
Cathode(K) Anode(A)
Sensor (5) • Generates potential difference when Cathode(K)
tension or pressure is applied.
Anode(A)
Flow of current
Capacitor • Component that temporarily stores Reference diode • Allows current to flow in one direction
electrical charge. (Zener diode) up to a certain voltage; allows current
to flow in the other direction once that
voltage is exceeded.
11

Form No. 5753-10-08F
Symbol Meaning
Extent of the change in the wiring position (1) • The wiring position can be exchanged freely within the
connector.
C
E A
E C A
B B B
B B B
F D B
F D B
Extent of the change in the wiring position (2) • The wiring position can be exchanged according to the
following combinations only.
C
E A Between A and B, Between C and D, Between E and F
B B B E C A
B B B
F D B F D B
Extent of the change in the wiring position (3) • The wiring position can be exchanged according to the
following combinations only.
3 2 1 2 1 Between 1, 2, 4 and 7.
L B B
5 4 • The wiring positions may be indicated by numbers for some
L B 4
connectors.
8 7 6
B/Y B R 7
SERVICE WARNING AND CAUTION FOR VEHICLES WITH SRS AIR BAG SYSTEM
If the SRS air bag system inspection is not performed correctly in accordance with the workshop manual procedures it could cause the system to operate
(deploy) accidentally, resulting in injury.
Always follow the service warnings and cautions in the workshop manual when performing the SRS air bag system-related inspection or servicing.
SERVICE WARNING FOR VEHICLES WITH DISCHARGE HEADLIGHTS

If the discharge headlight inspection and servicing is not done using the correct procedures in the workshop manual, it could result in electrical shock.
Always follow the service warnings and cautions in the workshop manual when performing the discharge headlight-related inspection or servicing.
ABBREVIATIONS USED IN THIS MANUAL

3GR THIRD GEAR CIS CONTINUOUS FUEL INJECTION SYSTEM
4GR FOURTH GEAR CKP CRANKSHAFT POSITION SENSOR
A AMPERE CM CONTROL MODULE
A/C AIR CONDITIONING CMP CAMSHAFT POSITION SENSOR
A/F AIR FUEL COMBI COMBINATION
AAS AUTO ADJUSTING SUSPENSION CON CONDITIONER
ABS ANTILOCK BRAKE SYSTEM CONT CONTROL
ACC ACCESSORIES CPU CENTRAL PROCESSING UNIT
ACV AIR CONTROL VALVE DEF DEFROSTER
ADD ADDITIONAL DI DISTRIBUTOR IGNITION
AIS AIR INJECTION SYSTEM DLC DATA LINK CONNECTOR
ALL AUTOMATIC LOAD LEVELING DLI DISTRIBUTORLESS IGNITION
AM AMPLITUDE MODULATION DOHC DOUBLE-OVERHEAD CAMSHAFT
AMP AMPLIFIER DRL DAYTIME RUNNING LIGHT
ANT ANTENNA DTC DIAGNOSTIC TROUBLE CODE(S)
ASV AIR SUPPLY VALVE DTM DIAGNOSTIC TEST MODE
AT AUTOMATIC TRANSMISSION ECPS ELECTRONICALLY CONTROLLED POWER
STEERING
ATX AUTOMATIC TRANSAXLE
ECT ENGINE CONTROL TEMPERATURE
B+ BATTERY POSITIVE VOLTAGE
EGR EXHAUST GAS RECIRCULATION
BAC BYPASS AIR CONTROL
EHPAS ELECTRO HYDRAULIC POWER ASSIST
CAN CONTROLLER AREA NETWORK STEERING
CIGAR CIGARETTE EI ELECTRONIC IGNITION
12

Form No. 5753-10-08F
ELEC ELECTRIC P/S POWER STEERING
ELR EMERGENCY LOCKING RETRACTOR PCM POWERTRAIN CONTROL MODULE
ET ELECTRONIC THROTTLE PJB PASSENGER JUNCTION BOX
EPS ELECTRIC POWER STEERING PNP PARK/NEUTRAL POSITION
EVAP EVAPORATIVE EMISSION PRC PRESSURE REGULATOR CONTROL
F FRONT PRG PURGE SOLENOID VALVE
F/I FUEL INJECTOR PSP POWER STEERING PRESSURE
FICB FAST-IDLE CAM BREAKER POSITIVE TEMPERATURE COEFFICIENT
PTC HEATER
FM FREQUENCY MODULATION
PWM PULSE WIDTH MODULATION
FP FUEL PUMP
QSS QUICK-START SYSTEM
FPR FUEL PUMP RELAY
R REAR
GEN GENERATOR
REC RECIRCULATION
GND GROUND
RF RIGHT FRONT
H/D HEATER/DEFROSTER
RH RIGHT HAND
HEAT HEATER
RPM REVOLUTIONS PER MINUTE
HI HIGH
RR RIGHT REAR
HO2S HEATED OXYGEN SENSOR
SAS SOPHISTICATED AIR BAG SENSOR
HS HIGH SPEED
SEQUENTIAL MULTIPOINT FUEL
HU HYDRAULIC UNIT SFI
INJECTION
IAC IDLE AIR CONTROL SOL SOLENOID
IAT INTAKE AIR TEMPERATURE SPV SPILL VALVE
IG IGNITION ST START
ILLUMI ILLUMINATION SW SWITCH
INT INTERMITTENT TC TURBOCHARGER
JB JOINT BOX TCC TORQUE CONVERTER CLUTCH
KS KNOCK SENSOR TRANSMISSION(TRANSAXLE) CONTROL
TCM
LCD LIQUID CRYSTAL DISPLAY MODULE
LF LEFT FRONT TCS TRACTION CONTROL SYSTEM
LH LEFT HAND TEMP TEMPERATURE
LO LOW TFT TRANSAXLE FLUID TEMPERATURE
LR LEFT REAR TICS TRIPLE INDUCTION CONTROL SYSTEM
M MOTOR TNS TAIL NUMBER SIDE LIGHTS
MAF MASS AIR FLOW TP THROTTLE POSITION SENSOR
MAP MANIFOLD ABSOLUTE PRESSURE TR TRANSMISSION(TRANSAXLE) RANGE
MFI MULTIPORT FUEL INJECTION TWS TOTAL WIRING SYSTEM
MID MIDDLE V VOLT
MIL MALFUNCTION INDICATOR LAMP VAF VOLUME AIR FLOW SENSOR
MIN MINUTE VENT VENTILATION
MIX MIXTURE VICS VARIABLE INERTIA CHARGING SYSTEM
MPX MULTIPLEX VOL VOLUME
MS MIDDLE SPEED VR VOLTAGE REGULATOR
MT MANUAL TRANSMISSION VARIABLE RESONANCE INDUCTION
VRIS
SYSTEM
MTX MANUAL TRANSAXLE
VSS VEHICLE SPEED SENSOR
N NEUTRAL
VTCS VARIABLE TUMBLE CONTROL SYSTEM
NC NORMALLY CLOSED
W WATT(S)
NO NORMALLY OPEN
WOT WIDE OPEN THROTTLE
O2S OXYGEN SENSOR
OBD ON-BOARD DIAGNOSTIC
O/D OVER DRIVE
OFF SWITCH OFF
ON SWITCH ON
OSC OSCILLATOR
P POWER
13

Form No. 5753-10-08F
00P Electrical System General Procedures
ELECTRICAL PARTS B6U000000006W03
Battery Cable
• Before disconnecting connectors or removing
electrical parts, disconnect the negative battery cable. NEGATIVE BATTERY CABLE
WGIWXX0007E
Wiring Harness
• To remove the wiring harness from the clip in the
engine room, pry up the hook of the clip using a
flathead screwdriver.
WGIWXX0039E
Caution
• Do not remove the Harness protective tape.
Otherwise, the wires could rub against the body,
which could result in water penetration and
electrical shorting.
CONNECTORS NO GOOD
WGIWXX0040E
Data Link Connector
• Insert the probe into the terminal when connecting a
jumper wire to the data link connector.
GOOD NO GOOD
Caution
• Inserting a jumper wire probe into the data link
connector terminal may damage the terminal.
X3U000WAY
Disconnecting Connectors
• When disconnecting connector, grasp the connectors,
not the wires.
NO GOOD
WGIWXX0041E
14

Form No. 5753-10-08F
Electrical System General Procedures 00P
• Connectors can be disconnected by pressing or
pulling the lock lever as shown.
WGIWXX0042E
Locking Connector
• When locking connectors, listen for a click indicating
they are securely locked.
X3U000WB1
Inspection
• When a tester is used to inspect for continuity or
measuring voltage, insert the tester probe from the
wiring harness side.
NO GOOD
WGIWXX0044E
• Inspect the terminals of waterproof connectors from

the connector side since they cannot be accessed
from the wiring harness side.
Caution
• To prevent damage to the terminal, wrap a thin
wire around the tester probe before inserting
into terminal.
NO GOOD
WGIWXX0045E
15

Form No. 5753-10-08F
00P Electrical System General Procedures
Terminals
Inspection
• Pull lightly on individual wires to verify that they are
secured in the terminal.
X3U000WB4
Replacement
• Use the appropriate tools to remove a terminal as
shown. When installing a terminal, be sure to insert it
until it locks securely.
• Insert a thin piece of metal from the terminal side of
the connector and with the terminal locking tab
pressed down, pull the terminal out from the
connector.
X3U000WB5
Sensors, Switches, And Relays

• Handle sensors, switches, and relays carefully. Do not
drop them or strike them against other objects. NO GOOD
X3U000WB6
Fuse
Replacement
• When replacing a fuse, be sure to replace it with one
of the same capacity. If a fuse fails again, the circuit
probably has a short and the wiring should be
inspected.
• Be sure the negative battery terminal is disconnected
before replacing a main fuse.
YMU000WA1
16

Form No. 5753-10-08F
Electrical System General Procedures 00P
• When replacing a pullout fuse, use the fuse puller.
YMU000WAK
ELECTRICAL TROUBLESHOOTING TOOLS

Jumper Wire
• A jumper wire is used to create a temporary circuit.
Connect the jumper wire between the terminals of a
circuit to bypass a switch.
Caution
• Do not connect a jumper wire from the power
source line to a body ground. This may cause
burning or other damage to wiring harnesses or
electronic components.
X3U000WBB
Voltmeter
• The DC voltmeter is used to measure circuit voltage. A
voltmeter with a range of 15 V or more is used by
connecting the positive (+) probe (red lead wire) to the
point where voltage will be measured and the negative
(-) probe (black lead wire) to a body ground.
X3U000WBC
Ohmmeter
• The ohmmeter is used to measure the resistance
between two points in a circuit and to inspect for
continuity and short circuits. POWER SOURCE LINE
Caution NO GOOD
• Do not connect the ohmmeter to any circuit
where voltage is applied. This will damage the
ohmmeter. GROUND LINE
OHMMETER
YMU000WAL
17

Form No. 5753-10-08F
ELECTRICAL WIRING SCHEMATIC 00E
18
THIS PAGE INTENTIONALLY
LEFT BLANK

00F
FUSE BOX
20
LEFT BLANK

COMMON CONNECTOR LIST 00C-1
22
Form No. 5753-1A-08E COMMON CONNECTOR LIST
23
00C-2
24
Form No. 5753-1A-08E COMMON CONNECTOR LIST
25
00C-4
26
LEFT BLANK

00G-a
GROUND POINT
28
HARNESS SYMBOL: (F) (E) (R)
[WL-C, WE-C]
3 [G6]
1 1
2
29
3
[WLT]
1 5 4
7
6
C-04
(F)-(R) WITH AIR BAG SYSTEM
(F)-(FR) WITHOUT AIR BAG SYSTEM
C-04
WITH AIR BAG SYSTEM (F)-(R)
WITHOUT AIR BAG SYSTEM (F)-(FR)
2
00G-a
00G-b
GROUND POINT
30
11 9
16
(R)-(DR3) 10
C-15
13
14
12
C-03
31
(F)-(R)
C-03
(F)-(R)
00G-b
Mazda BT-50 Wiring Diagram (5753-1A-08E) (5753-10-08F)
00D-a
DATA LINK CONNECTOR
32 Revised 12/2010 (Ref. No. L088/10)

16
[WL-C, WE-C] MAIN FUSE BLOCK
MAIN FUSE BLOCK (REFER TO 00F SECTION)
(REFER TO 00F SECTION) F-01
F-01 3
[G6] [GRAY]
DATA LINK CONNECTOR
[GRAY]
1
1
DATA LINK CONNECTOR D-01
D-01
C-27
(F)-(INJ)
[BLACK]
33
2 2
[WLT]
MAIN FUSE BLOCK
(REFER TO 00F SECTION)
F-01 3 [GRAY]
DATA LINK CONNECTOR
D-01
1
F-02
FUSE BLOCK
C-01
ENGINE SWITCH WL-C, WE-C, WLT
IGNITION SWITCH G6
00D-a
00D-b
DATA LINK CONNECTOR
34 Revised 12/2010 (Ref. No. L088/10)

(F)-(F2)
C-09 (F)-(F2)
C-09
[WL-C, WE-C] 16
MAIN FUSE BLOCK
(REFER TO 00F SECTION) MAIN FUSE BLOCK
F-01 3 (REFER TO 00F SECTION)
F-01
[G6]
C-27
(F)-(INJ)
[BLACK]
35
(F)-(F2)
C-09
[WLT]
MAIN FUSE BLOCK
(REFER TO 00F SECTION) 3
F-01
(F)-(F2)
C-09
5
F-02
FUSE BLOCK
D-02
DATA LINK CONNECTOR-2
[BLACK]
00D-b
0114
FUEL SYSTEM
36
9
FUEL PUMP
10
0922-107
MAIN FUSE BLOCK
(REFER TO 00F SECTION) (R)-(R2)
F-01 C-13
C-02
(F)-(R)
37
(F)-(R)
C-02
F-02
FUSE BLOCK
C-01
IGNITION SWITCH
0114-01
FUEL PUMP RELAY
01 ENGINE
14 FUEL SYSTEM 0114
0117
CHARGING SYSTEM
38
MAIN FUSE BLOCK

[BLACK]
(F)-(E) F-01 [BLACK]
(F)-(E)
C-05
C-05
[WL-C, WE-C]
MAIN FUSE BLOCK
(REFER TO 00F SECTION) [G6]
F-01
0117-01
GENERATOR
[GRAY]
39
0117-01
GENERATOR
[GRAY] [GRAY]
0117-01 [WLT] (F)-(E)
GENERATOR C-06 0117-01
MAIN FUSE BLOCK GENERATOR
F-01
0117-01
GENERATOR
[GRAY]
0117-01
GENERATOR
01 ENGINE
17 CHARGING SYSTEM 0117
0119
STARTING SYSTEM
40
[BLACK]
[WL-C, WE-C] (F)-(E)
[BLACK]
C-05 (F)-(E)
MAIN FUSE BLOCK [GRAY]
[G6] (F)-(E) C-05
F-01 [GRAY] C-06
(F)-(E)
MAIN FUSE BLOCK
C-06 (REFER TO 00F SECTION)
DIGITAL TRANSMISSION RANGE SENSOR F-01
1 0119-03
[GRAY]
(F)-(E)
C-30
[BLACK]
0119-01
41
STARTER
[WLT] (F)-(E)
C-05 2 0119-01
MAIN FUSE BLOCK STARTER
F-01 [GRAY]
(F)-(E)
C-06
F-02
FUSE BLOCK
C-01
IGNITION SWITCH G6
0119-01
STARTER
0119-02
STARTER RELAY
01 ENGINE
19 STARTING SYSTEM 0119
CONTROL SYSTEM (WL-C, WE-C) 0140-1a
42
[BROWN]
GLOW PLUG RELAY
MAIN FUSE BLOCK 0140-103
F-01 [GRAY]
(F)-(E) NEUTRAL SWITCH
C-06 0140-107
GLOW PLUG RELAY
0140-103
1
43
MAIN RELAY
4
0140-102
2 5
[BLACK]
PCM
0140-105 0140-104
GLOW PLUG (F)-SHORT CORD 0140-101
F-02
FUSE BLOCK
C-01
ENGINE SWITCH
0140-106
CLUTCH PEDAL POSITION SWITCH
01 ENGINE
40 CONTROL SYSTEM 0140-1a
CONTROL SYSTEM (WL-C, WE-C) 0140-1b
44
[BLACK]
FUEL INJECTOR No.3
0140-114
[GRAY] [BLACK]
(F)-(E) FUEL INJECTOR No.4
C-06 0140-115
0140-113
FUEL INJECTOR No.2
[BLACK]
0140-112
FUEL INJECTOR No.1
[BLACK]
0140-108
MASS AIR FLOW SENSOR/
45
INTAKE AIR TEMPERATURE SENSOR No.2

0140-111 [BLACK]
FUEL METERING VALVE
[BLACK]
0140-109
0140-110 INTAKE SHUTTER SOLENOID VALVE
INTAKE SHUTTER SOLENOID VALVE (HALF)
(FULL) [GREEN] [BLACK]
[BROWN] PCM
0140-101
01 ENGINE
40 CONTROL SYSTEM 0140-1b
CONTROL SYSTEM (WL-C, WE-C) 0140-1c
46
[GRAY]
EGR VALVE POSITION SENSOR
0140-117
[BLACK]
EGR SOLENOID VALVE
0140-121
[BLACK]
VARIABLE BOOST CONTROL SOLENOID VALVE
0140-122
0140-119
47
VARIABLE SWIRL CONTROL

SOLENOID VALVE 0140-120
[BROWN] EGR CONTROL SOLENOID VALVE
[GREEN]
0140-118
CAMSHAFT POSITION SENSOR
[BLACK]
0140-116
FUEL PRESSURE SENSOR
[BLACK]
[BLACK]
PCM
0140-101
01 ENGINE
40 CONTROL SYSTEM 0140-1c
CONTROL SYSTEM (WL-C, WE-C) 0140-1d
48
[BLACK]
BOOST SENSOR/
INTAKE AIR TEMPERATURE SENSOR No.1
0140-123
[GRAY]
(F)-(E)
C-06
0140-128
CRANKSHAFT POSITION SENSOR
[BLACK]
0922-106
(F)-SHORT CORD
[BLACK]
49
0922-105
ENGINE COOLANT 4
TEMPERATURE SENSOR
[GRAY] [BLACK]
PCM
5
0140-127 0140-101
FUEL TEMPERATURE SENSOR
0140-124
IDLE SWITCH
01 ENGINE
40 CONTROL SYSTEM 0140-1d
0140-1e
CONTROL SYSTEM (WL-C, WE-C)
50 Revised 12/2010 (Ref. No. L088/10)

[BLACK]
ACCELERATOR PEDAL POSITION SENSOR
0140-129
4
[BLACK]
PCM
0140-101
51
01 ENGINE
40 CONTROL SYSTEM 0140-1e
CONTROL SYSTEM (WLT WITHOUT IMMOBILIZER SYSTEM) 0140-2a
52
[BLACK]
FICD SOLENOID VALVE No. 1
0140-205
[BLACK]
FUEL CUT VALVE(FCV)
0140-209 FICD SOLENOID VALVE No. 2

3
[GRAY] [BLACK] 0140-206
(F)-(E) (F)-(E)
[GRAY]
[BROWN]
C-06 C-05 ENGINE COOLANT
GLOW PLUG RELAY TEMPERATURE SENSOR
0140-202 0140-207
F-01
MAIN FUSE BLOCK
53
0140-202
GLOW PLUG RELAY
4
5
0140-208
CKP SENSOR
[GRAY]
0140-204
GLOW PLUG
0140-201
PCM
F-02
FUSE BLOCK
C-01
ENGINE SWITCH
01 ENGINE
CONTROL SYSTEM (WLT WITHOUT IMMOBILIZER SYSTEM) 0140-2b
54
55
0140-201
PCM
01 ENGINE
CONTROL SYSTEM (WLT WITH IMMOBILIZER SYSTEM) 0140-3a
56
[BLACK]
GLOW PLUG RELAY
0140-305
0140-302
[GRAY]
(F)-(E)
[BLACK] 0140-306
(F)-(E)
C-06 C-05 [GRAY]
[BROWN] 3 ENGINE COOLANT
GLOW PLUG RELAY TEMPERATURE SENSOR
0140-302 0140-307
F-01
MAIN FUSE BLOCK
57
0140-309
INJECTION PUMP
[GRAY]
4
0140-308 5
CKP SENSOR
[GRAY]
0140-304
GLOW PLUG
0140-301
PCM
[BLACK]
F-02
FUSE BLOCK
C-01
ENGINE SWITCH
01 ENGINE
CONTROL SYSTEM (WLT WITH IMMOBILIZER SYSTEM) 0140-3b
58
3
59
0140-310
EGR SOLENOID VALVE
[GREEN]
0140-301
PCM
[BLACK]
01 ENGINE
CONTROL SYSTEM (G6) 0140-4a
60
16
MAIN FUSE BLOCK

F-01
MAIN RELAY
0140-402
0140-404
CONDENSER
[BLACK]
C-27 0140-406
(F)-(INJ)
[BLACK] IGNITION COIL
61
5
0140-405
2 IGNITER
[GRAY]
0140-403
CAMSHAFT
POSITION SENSOR
[GRAY]
0140-401
PCM
[YELLOW]
F-02
FUSE BLOCK
C-01
IGNITION SWITCH
01 ENGINE
CONTROL SYSTEM (G6) 0140-4b
62
[GRAY]
FUEL INJECTOR No.2
0140-407
[GRAY]
FUEL INJECTOR No.3
0140-410
[BLACK] [BLACK]
PURGE SOLENOID IAC VALVE
VALVE
0140-414
0140-412 THROTTLE POSITION SENSOR
[ORANGE] 0140-416
PRC SOLENOID
VALVE [GRAY]
FUEL INJECTOR No.4
0140-411
0140-408
[GRAY]
FUEL INJECTOR No.1
0140-409
0140-417
63
OXYGEN SENSOR
[BLACK]
C-27
(F)-(INJ)
[BLACK]
0140-415
INTAKE AIR
TEMPERATURE SENSOR
[BLACK]
0140-418
ENGINE COOLANT 0140-413
TEMPERATURE SENSOR MASS AIR FLOW SENSOR
[BLACK] [GRAY]
0140-401
PCM
[YELLOW]
01 ENGINE
CONTROL SYSTEM (G6) 0140-4c
64
[GRAY]
(F)-(E) NEUTRAL SWITCH
C-06 0140-421
1
65
0140-419 4
CTP SWITCH 5
0140-422
POWER STEERING
PRESSURE SWITCH
2
0140-420 0140-401
CLUTCH SWITCH PCM
[YELLOW]
01 ENGINE
40 CONTROL SYSTEM 0140-4c
REMOTE FREEWHEEL CONTROL SYSTEM (WL-C, WE-C) 0318-1a
66
RFW FREE SOLENOID

0318-102
[BLUE]
RFW LOCK SOLENOID
0318-101
MAIN FUSE BLOCK

F-01
67
RFW MAIN SWITCH

5
0318-103
[BLACK]
PCM
0140-101
F-02
FUSE BLOCK
C-01
ENGINE SWITCH
03 DRIVELINE/AXLE
18 4-WHEEL DRIVE 0318-1a
REMOTE FREEWHEEL CONTROL SYSTEM (WL-C, WE-C) 0318-1b
68
[BROWN]
[BLACK] TRANSFER NEUTRAL SWITCH
(F)-(E)
0318-105
C-05
[BLACK]
4 4 INDICATOR SWITCH
[GRAY] 0318-104
(F)-(E)
C-06
1
69
0318-106
RFW SWITCH
[BLACK]
[BLACK]
PCM
0140-101
2
03 DRIVELINE/AXLE
18 4-WHEEL DRIVE 0318-1b
REMOTE FREEWHEEL CONTROL SYSTEM (WLT) 0318-2
70
[BLUE]
RFW LOCK SOLENOID RFW FREE SOLENOID
0318-202 0318-203
[BLACK]
[BLACK]
TRANSFER NEUTRAL SWITCH
(F)-(E)
[GRAY]
(F)-(E) C-05 0318-207
C-06 [BLACK]
3 4 4 INDICATOR SWITCH
MAIN FUSE BLOCK
(REFER TO 00F SECTION) 0318-206
F-01
71
RFW MAIN SWITCH

5
0318-204
0318-205
RFW SWITCH
[BLACK]
6
F-02
FUSE BLOCK
C-01
ENGINE SWITCH
0318-201
RFW CONTROL MODULE
03 DRIVELINE/AXLE
18 4-WHEEL DRIVE 0318-2
0318-3a
4X4 CONTROL SYSTEM
72 Revised 12/2010 (Ref. No. L088/10)

FREE SOLENOID
0318-303
[BLUE]
LOCK SOLENOID
0318-302
MAIN FUSE BLOCK

F-01
4 4 RELAY
0318-304
73
CHECK CONNECTOR
0318-308
[GRAY]
4 4 CONTROL MODULE
0318-301
5
Revised 12/2010 (Ref. No. L088/10)
F-02
FUSE BLOCK
C-01
ENGINE SWITCH
03 DRIVELINE/AXLE
18 4-WHEEL DRIVE 0318-3a
4X4 CONTROL SYSTEM 0318-3b
74
SPEED SENSOR/
CLUTCH COIL
0318-306
(F)-(E)
MOTOR COMPONENT
C-31
0318-305
[GRAY]
(F)-(E)
C-06
DIGITAL TRANSMISSION RANGE SENSOR
1 0119-03
[GRAY]
(F)-(E)
[GRAY]
(F)-(E) C-29
C-30
C-02
(F)-(R)
C-03
(F)-(R)
75
0318-307
2 4 4 SWITCH
[GRAY] 4
4 4 CONTROL MODULE
0318-301
5
C-03
(F)-(R) C-02
(F)-(R)
03 DRIVELINE/AXLE
18 4-WHEEL DRIVE 0318-3b
4-WHEEL ANTILOCK BRAKE SYSTEM (4W-ABS) 0413
76
[GRAY]
ABS WHEEL-SPEED SENSOR LR
(F)-(F2) 0413-04
C-09
[BLACK] [GRAY]
ABS HU/CM ABS WHEEL-SPEED SENSOR RR
11
0413-01 (F)-(F2)
0413-05
C-08
(R)-(F2)
MAIN FUSE BLOCK C-14
F-01 (R)-(R2)
C-13
[BLACK]
G SENSOR
0413-06
0413-03
ABS WHEEL-SPEED SENSOR RF
[GRAY]
C-14
(R)-(F2)
77
0413-02
ABS WHEEL-SPEED SENSOR LF (F)-(F2)
[GRAY]
C-09
(F)-(F2)
C-08
F-02
FUSE BLOCK
C-01
IGNITION SWITCH G6
04 BRAKES
13 ANTILOCK BRAKE SYSTEM 0413
AUTOMATIC TRANSMISSION CONTROL SYSTEM 0513-a
78
(F)-(E)
C-31
MAIN FUSE BLOCK
F-01
1
[GRAY]
(F)-(E)
C-30
C-02
(F)-(R)
79
0513-01
TCM
2
0513-04
O/D OFF SWITCH
0513-02
AT RELAY
[BLACK]
AT DIODE
0513-03
C-02
(F)-(R)
F-02
FUSE BLOCK
C-01
ENGINE SWITCH
13 AUTOMATIC TRANSMISSION 0513-a
AUTOMATIC TRANSMISSION CONTROL SYSTEM 0513-b
80
[BLACK]
(F)-(E)
C-05 INTERMEDIATE SHAFT SPEED SENSOR
0513-06
[GRAY]
(F)-(E)
C-06
[GRAY]
(F)-(E)
C-30
0513-05
81
TURBINE SHAFT SPEED SENSOR
0513-01
TCM
13 AUTOMATIC TRANSMISSION 0513-b
AUTOMATIC TRANSMISSION CONTROL SYSTEM 0513-c
82
SOLENOID BODY
0513-08
83
0513-01
TCM
13 AUTOMATIC TRANSMISSION 0513-c
AUTOMATIC TRANSMISSION CONTROL SYSTEM 0513-d
84
(F)-(E)
OUTPUT SHAFT SPEED SENSOR
C-31
0513-07
DIGITAL TRANSMISSION RANGE SENSOR

1
0119-03
85
0513-01
TCM
13 AUTOMATIC TRANSMISSION 0513-d
0740
M
HEATER AND AIR CONDITIONER
86 Revised 9/2010 (Ref. No. L061/10)

[BLACK]
(F)-(E)
C-05
[WL-C, WE-C] MAIN FUSE BLOCK
A/C RELAY (REFER TO 00F SECTION)
0740-07 F-01
MAIN FUSE BLOCK
(REFER TO 00F SECTION) [G6]
F-01
0740-07
A/C RELAY
0740-08
MAGNETIC CLUTCH
0740-08
MAGNETIC CLUTCH
0740-09
0740-09 REFRIGERANT PRESSURE SWITCH
[BLACK]
87
REFRIGERANT PRESSURE SWITCH

[BLACK]
A/C RELAY
BLOWER RELAY
0740-07
0740-02 WL-C, WE-C
[GRAY]
[WLT] (F)-(E)
C-06
4
MAIN FUSE BLOCK
(REFER TO 00F SECTION) 5
F-01 A/C SWITCH
0740-11
F-02
FUSE BLOCK
C-01
0740-06 0740-10 IGNITION SWITCH G6
A/C AMPLIFIER
BLOWER MOTOR
0740-04 0740-01
0740-08 RESISTOR 0740-03 CLIMATE CONTROL UNIT
MAGNETIC CLUTCH WLT, G6 0740-02 0740-05 (F)-BLOWER UNIT
BLOWER RELAY
0740-09 RESISTOR
REFRIGERANT PRESSURE SWITCH
[BLACK]
07 HEATER, VENTILATION & AIR CONDITIONING (HVAC)

40 CONTROL SYSTEM 0740
AIR BAG SYSTEM (INCLUDES PRE-TENSIONER SEAT BELT INFORMATION) 0810-1a
88
MAIN FUSE BLOCK

F-01
89
[YELLOW]
SHORT CONNECTOR
DRIVER-SIDE AIR BAG MODULE
0810-102 0810-105
[YELLOW]
PASSENGER-SIDE AIR BAG MODULE
0810-104
0810-103
(F)-CLOCK SPRING
[YELLOW]
6
F-02
FUSE BLOCK
C-01
0810-101 ENGINE SWITCH WL-C, WE-C, WLT
SAS CONTROL MODULE IGNITION SWITCH G6
[YELLOW]
08 RESTRAINTS
10 AIR BAG SYSTEM 0810-1a
AIR BAG SYSTEM (INCLUDES PRE-TENSIONER SEAT BELT INFORMATION) 0810-1b
90
[YELLOW]
(R)-(DR3)
C-16 [YELLOW]
DRIVER-SIDE PRE-TENSIONER SEAT BELT
[YELLOW] 0810-106
[BLACK]
0810-106 DRIVER-SIDE SIDE AIR BAG SENSOR
[BLACK] 0810-110
DRIVER-SIDE SIDE AIR BAG SENSOR
0810-110
[DOUBLE CAB]
[FREESTYLE CAB]
C-18 0810-107
(R)-(DR4) PASSENGER-SIDE PRE-TENSIONER SEAT BELT
[YELLOW]
0810-107 [YELLOW]
PASSENGER-SIDE PRE-TENSIONER SEAT BELT
[YELLOW]
0810-111
PASSENGER-SIDE SIDE AIR BAG SENSOR
0810-111 0810-108 [BLACK]

DRIVER-SIDE SIDE AIR BAG MODULE
PASSENGER-SIDE SIDE AIR BAG SENSOR [YELLOW]
[BLACK]
0810-108 0810-101
91
SAS CONTROL MODULE

DRIVER-SIDE SIDE AIR BAG MODULE [YELLOW] 0810-109
[YELLOW]
PASSENGER-SIDE SIDE AIR BAG MODULE
[YELLOW]
0810-109 [YELLOW]
PASSENGER-SIDE SIDE AIR BAG MODULE
0810-101 [YELLOW] 0810-106
SAS CONTROL MODULE
[YELLOW]
[REGULAR CAB]
0810-107
PASSENGER-SIDE PRE-TENSIONER SEAT BELT
[YELLOW]
0810-101
SAS CONTROL MODULE
[YELLOW]
08 RESTRAINTS
10 AIR BAG SYSTEM 0810-1b
REAR WINDOW DEFROSTER 0912-1
92
[BLACK]
FILAMENT
0912-103
MAIN FUSE BLOCK
F-01
0912-103
FILAMENT
14 [BLACK]
C-02
(F)-(R)
93
REAR WINDOW DEFROSTER RELAY
0912-101 WLT, G6
5
REAR WINDOW DEFROSTER SWITCH
0912-102
0912-101 WL-C, WE-C

REAR WINDOW DEFROSTER RELAY
C-02
(F)-(R)
F-02
FUSE BLOCK
C-01
IGNITION SWITCH G6
09 BODY & ACCESSORIES

12 GLASS/WINDOWS/MIRRORS 0912-1
POWER WINDOW SYSTEM 0912-2a
94
POWER WINDOW MAIN SWITCH-

FRONT POWER WINDOW REGULATOR RH
MAIN FUSE BLOCK
(REFER TO 00F SECTION) 0912-209
F-01
POWER WINDOW MAIN SWITCH
0912-201
[BLUE]
FRONT POWER WINDOW REGULATOR RH
0912-205
(F)-(DR1)
C-11
C-02 0912-202
(F)-(R)
POWER WINDOW SUBSWITCH LF
0912-206
FRONT POWER WINDOW REGULATOR LH
C-12
95
(F)-(DR2)
5 (F)-(DR1)
C-11
(F)-(DR2)
C-12
C-02
(F)-(R)
F-02
FUSE BLOCK
C-01
IGNITION SWITCH G6

12 GLASS/WINDOWS/MIRRORS 0912-2a
POWER WINDOW SYSTEM 0912-2b
96
(F)-(DR1)
C-11
C-02
(F)-(R)
C-04 POWER WINDOW SUBSWITCH RR

(F)-(R)
WITH AIR BAG SYSTEM 0912-203 REAR POWER WINDOW REGULATOR RH
97

0912-207
(R)-(DR3)
C-20
(R)-(DR3)
C-19
POWER WINDOW MAIN SWITCH
0912-201
(F)-(DR1)
C-11
0912-208
0912-204 REAR POWER WINDOW REGULATOR LH
POWER WINDOW SUBSWITCH LR
C-23
(R)-(DR4) WITH AIR BAG SYSTEM
C-02 (FR)-(DR4) WITHOUT AIR BAG SYSTEM
(F)-(R)
C-22
(FR)-(DR4) WITHOUT AIR BAG SYSTEM
C-04

12 GLASS/WINDOWS/MIRRORS 0912-2b
POWER OUTER MIRROR 0912-3
98
MAIN FUSE BLOCK

POWER OUTER MIRROR SWITCH
F-01
0912-301
POWER OUTER MIRROR RH
0912-303
(F)-(DR1)
(F)-(DR1)
C-10
C-11
0912-302
POWER OUTER MIRROR LH
C-12
(F)-(DR2)
99
(F)-(DR1)
C-10
4
5
(F)-(DR1)
C-11
(F)-(DR2)
C-12
F-02
FUSE BLOCK
C-01
IGNITION SWITCH G6

12 GLASS/WINDOWS/MIRRORS 0912-3
POWER DOOR LOCK SYSTEM 0914-1a
100
MAIN FUSE BLOCK

F-01
DOOR LOCK-LINK SWITCH
0914-102
(F)-(DR1)
C-10
(F)-(DR1)
C-11
101
DOOR LOCK CONTROL MODULE

WLT, G6 0914-101

WL-C, WE-C 0914-101
(F)-(DR1)
5 4 C-10
(F)-(DR1)
C-11
F-02
FUSE BLOCK

14 SECURITY AND LOCKS 0914-1a
POWER DOOR LOCK SYSTEM 0914-1b
102

WLT, G6 0914-101

WL-C, WE-C 0914-101
(F)-(DR1)
C-10
(F)-(DR2)
C-12
C-02
(F)-(R)
103
[GRAY]
DOOR LOCK ACTUATOR RR
C-04 0914-105
WITH AIR BAG SYSTEM (F)-(R)
(R)-(DR3)
C-20
DOOR LOCK ACTUATOR RF
0914-103
(F)-(DR1)
C-10
0914-106
DOOR LOCK ACTUATOR LR
[GRAY]
C-23
0914-104
C-02 DOOR LOCK ACTUATOR LF
(F)-(R)
C-04
C-12
(F)-(DR2)

14 SECURITY AND LOCKS 0914-1b
KEYLESS CONTROL MODULE 0914-2
104
MAIN FUSE BLOCK

F-01
105
F-02
FUSE BLOCK
C-01
IGNITION SWITCH G6
0914-201
KEYLESS CONTROL MODULE

14 SECURITY AND LOCKS 0914-2
IMMOBILIZER SYSTEM 0914-3
106
[WL-C, WE-C] COIL

F-01
3
IMMOBILIZER UNIT
0914-301
F-02
FUSE BLOCK
C-01
ENGINE SWITCH
107
[WLT]
MAIN FUSE BLOCK
F-01 3
[GRAY]
INJECTION PUMP
0140-309

14 SECURITY AND LOCKS 0914-3
THEFT-DETERRENT SYSTEM 0914-4a
108
[BLACK]
BONNET SWITCH
0914-403 DOOR KEY CYLINDER SWITCH RF
MAIN FUSE BLOCK

0914-102
F-01
(F)-(DR1)
C-11
0914-402
DOOR KEY CYLINDER SWITCH LF
C-12
(F)-(DR2)
109
(F)-(DR1)
5
C-11
THEFT-DETERRENT CONTROL MODULE
0914-401
(F)-(DR2)
C-12
6
F-02
FUSE BLOCK
C-01
ENGINE SWITCH

14 SECURITY AND LOCKS 0914-4a
THEFT-DETERRENT SYSTEM 0914-4b
110
[GRAY]
DOOR LOCK-LINK SWITCH RR
0914-405
MAIN FUSE BLOCK
F-01 (R)-(DR3)
C-21
0914-406
THEFT-DETERRENT HORN RELAY
0914-404
DOOR LOCK-LINK SWITCH LR
[GRAY]
C-24
8 (FR)-(DR4) WITHOUT AIR BAG SYSTEM
12
C-02
(F)-(R)
C-04
111

C-03
(F)-(R)
0914-407
THEFT-DETERRENT HORN
4
5
THEFT-DETERRENT CONTROL MODULE

0914-401
C-02
(F)-(R)
C-03
(F)-(R)
F-02
FUSE BLOCK
C-04

14 SECURITY AND LOCKS 0914-4b
0918-1
HEADLIGHT
112
MAIN FUSE BLOCK

F-01
[BLACK]
HEADLIGHT RH
0918-105
C-03
(F)-(R)
113
HEADLIGHT RELAY
0918-104 0918-102 WLT, G6

HEADLIGHT LH
[BLACK]
0918-101
HEADLIGHT SWITCH
6 [GRAY]
0918-103 WL-C, WE-C

TNS RELAY
C-03
(F)-(R) 0918-102 WL-C, WE-C
HEADLIGHT RELAY
F-02
FUSE BLOCK
WLT, G6 0918-103
TNS RELAY

18 LIGHTING SYSTEMS 0918-1
LICENSE PLATE LIGHT / PARKING LIGHT / TAILLIGHT 0918-2
114
[GRAY]
PARKING LIGHT RH
0918-202
[BLACK]
TAILLIGHT RH
0918-204
[GRAY]
9 LICENSE PLATE LIGHT RH
0918-205
115
(R)-(R2) [BLACK]
C-13 TAILLIGHT LH
0918-201 0918-203
2
PARKING LIGHT LH
[GRAY]
0918-206
LICENSE PLATE LIGHT LH
[GRAY]
10

0918-3
FRONT FOG LIGHT
116
MAIN FUSE BLOCK

F-01
0918-303
FRONT FOG LIGHT RH
[BLACK]
FRONT FOG LIGHT RELAY
117
0918-301 WLT
0918-302
FRONT FOG LIGHT LH
[BLACK]
5
0918-101
6 0918-301 WL-C, WE-C
FRONT FOG LIGHT SWITCH
FRONT FOG LIGHT RELAY [GRAY]
F-02
FUSE BLOCK

TURN AND HAZARD WARNING LIGHT 0918-4
118
[GRAY] [BLACK]
FRONT SIDE TURN LIGHT RH REAR TURN LIGHT RH
0918-405 0918-204
MAIN FUSE BLOCK

9 10 [BLACK]
REAR TURN LIGHT LH
F-01 (R)-(R2)
0918-203
C-13
[GRAY]
1
FRONT SIDE TURN LIGHT LH
FRONT TURN LIGHT RH
0918-406
0918-403
C-03
(F)-(R)
119
0918-404
FRONT TURN LIGHT LH
2
FLASHER CONTROL MODULE
WLT, G6 0918-401
FLASHER CONTROL MODULE

WL-C, WE-C 0918-401
5 4
HAZARD WARNING SWITCH
0918-402
6 0918-101
C-03 TURN SWITCH
F-02 (F)-(R)
[GRAY]
FUSE BLOCK
C-01
IGNITION SWITCH G6

0918-5
BACK-UP LIGHT
120
[BLACK]
(F)-(E)
[BLACK]
C-05 BACK-UP LIGHT SWITCH
0918-501
[WL-C, WE-C]
MAIN FUSE BLOCK
F-01 DIGITAL TRANSMISSION RANGE SENSOR
0119-03
C-03
(F)-(R)
F-02
FUSE BLOCK
C-01
IGNITION SWITCH G6
[BLACK]
BACK-UP LIGHT RH
0918-204
121
(R)-(R2) 10 [BLACK]
BACK-UP LIGHT LH
C-13
[BLACK] 0918-203
[WLT, G6] (F)-(E)
C-05 BACK-UP LIGHT SWITCH
F-01
C-03
(F)-(R)

BRAKE LIGHT / HIGH-MOUNT BRAKE LIGHT 0918-6
122
[BLACK]
BRAKE LIGHT RH
0918-204
HIGH-MOUNT BRAKE LIGHT 9
0918-602 [BLACK]
MAIN FUSE BLOCK (R)-(DR3) 10 BRAKE LIGHT LH
C-15 0918-203
F-01 (R)-(R2)
C-13
13
123
C-03
(F)-(R)
BRAKE SWITCH
0918-601 4
C-03
(F)-(R)
F-02
FUSE BLOCK

ILLUMINATION LIGHT 0918-7a
124
REAR WINDOW DEFROSTER SWITCH ILLUMINATION
0912-102 INSTRUMENT CLUSTER ILLUMINATION
0922-101
HAZARD WARNING SWITCH ILLUMINATION
0918-402
AUDIO UNIT ILLUMINATION
0920-201
C-02
(F)-(R)
0918-701
HEATER CONTROL ILLUMINATION
125
C-02
(F)-(R)
0513-04
O/D OFF SWITCH ILLUMINATION
0918-706
4 4 SWITCH ILLUMINATION

18 LIGHTING SYSTEMS 0918-7a
ILLUMINATION LIGHT 0918-7b
126
RFW MAIN SWITCH ILLUMINATION
0318-103
0318-204
4 [BLUE]
PANEL LIGHT CONTROL SWITCH
0918-704
5
A/C SWITCH ILLUMINATION
0740-11
127
0918-702
CONSOLE ILLUMINATION
0918-703 [BLACK]
GLOVE COMPARTMENT LIGHT

[BLACK]

18 LIGHTING SYSTEMS 0918-7b
0918-8
INTERIOR LIGHT
128
MAIN FUSE BLOCK

(REFER TO 00F SECTION) [FREESTYLE CAB] (R)-(DR3)
F-01 INTERIOR LIGHT
C-15 (R)-(DR4) WITH AIR BAG SYSTEM
0918-801 C-17
[BLACK]
DOOR SWITCH RF
0918-802
INTERIOR LIGHT
[BLACK] 0918-801
DOOR SWITCH RF
0918-802
0918-803
DOOR SWITCH LF
[BLACK]
C-03 [REGULAR CAB]

(F)-(R)
C-07
(F)-(IN)
C-04 0918-803
(F)-(R) WITH AIR BAG SYSTEM DOOR SWITCH LF
[BLACK]
129
C-03
(F)-(R) C-04
C-07
(F)-(IN)
INTERIOR LIGHT
0918-801
[BLACK]
DOOR SWITCH RR
0918-804
(F)-(IN)
C-07
[DOUBLE CAB]
C-03
(F)-(R)
F-02
FUSE BLOCK
0918-805
DOOR SWITCH LR
[BLACK]
0918-802
DOOR SWITCH RF
C-04 [BLACK] 0918-803
WITH AIR BAG SYSTEM (F)-(R) C-03
(F)-(R) DOOR SWITCH LF
WITHOUT AIR BAG SYSTEM (F)-(FR) [BLACK]
C-04
C-07 (F)-(R)
(F)-(FR)
WITH AIR BAG SYSTEM
(F)-(IN) WITHOUT AIR BAG SYSTEM

WINDSHIELD WIPER AND WASHER 0919
130
MAIN FUSE BLOCK

F-01
WINDSHIELD WIPER MOTOR

1 0919-02
131
0919-03
WINDSHIELD WASHER MOTOR
5
2
0919-01
WINDSHIELD WIPER AND WASHER SWITCH
[BLACK]
F-02
FUSE BLOCK
C-01
IGNITION SWITCH G6

19 WIPER/WASHER SYSTEM 0919
ACCESSORY SOCKET / CIGARETTE LIGHTER 0920-1
132
MAIN FUSE BLOCK

F-01
133
F-02
FUSE BLOCK
C-01 (REFER TO 00F SECTION)
0920-101 ENGINE SWITCH WL-C, WE-C, WLT
IGNITION SWITCH G6
CIGARETTE LIGHTER
[BLACK]
0920-102
ACCESSORY SOCKET
[BLACK]

20 ENTERTAINMENT 0920-1
0920-2a
AUDIO SYSTEM
134
MAIN FUSE BLOCK

F-01
[BLACK]
TWEETER RH
0920-207
(F)-(DR1)
FRONT SPEAKER RH
C-11
0920-206
0920-204
TWEETER LH
[BLACK]
0920-205
135
FRONT SPEAKER LH
C-12
(F)-(DR2)
7
AUDIO UNIT (F)-(DR1)
0920-201 C-11
(F)-(DR2)
C-12
F-02
FUSE BLOCK
C-01
IGNITION SWITCH G6

20 ENTERTAINMENT 0920-2a
0920-2b
AUDIO SYSTEM 136 Revised 3/2009 (Ref. No. L002/09)
4
REAR SPEAKER RH
5 0920-203
AUDIO UNIT (R)-(DR3)
AUDIO UNIT 0920-201 C-19
0920-201

[DOUBLE CAB]
C-03
(F)-(R)
0920-202
REAR SPEAKER LH
C-22
C-03
(F)-(R) C-04
C-04 0920-208 (F)-(R) WITH AIR BAG SYSTEM
WITH AIR BAG SYSTEM (F)-(R) (F)-(FR) WITHOUT AIR BAG SYSTEM
AUXILIARY JACK
137
(R)-(DR3)
C-15
REAR SPEAKER RH
0920-203
[FREESTYLE CAB,
Revised 3/2009 (Ref. No. L002/09)
REGULAR CAB]
C-17
0920-202 (FR)-(DR4) WITHOUT AIR BAG SYSTEM
REAR SPEAKER LH
C-03 C-04
(F)-(R) (F)-(R) WITH AIR BAG SYSTEM

20 ENTERTAINMENT 0920-2b
INSTRUMENT CLUSTER 0922-1a
138
[BROWN]
VEHICLE SPEEDOMETER SENSOR
0922-104 4 2 [GRAY]
[WL-C, WE-C] [GRAY]
[G6] (F)-(E) [GRAY]
VEHICLE SPEEDOMETER SENSOR C-06 VEHICLE SPEEDOMETER SENSOR
MAIN FUSE BLOCK
[GRAY]
0922-104 4 4 (REFER TO 00F SECTION) 0922-104
(F)-(E)
C-06 F-01
MAIN FUSE BLOCK 3
F-01
0922-105
WATER TEMPERATURE
SENDER UNIT
([GRAY]) G6
0922-106 FUEL GAUGE SENDER UNIT
(F)-SHORT CORD 0922-107
[BLACK]
0922-105 (R)-(R2)
C-13
139
WATER TEMPERATURE SENDER UNIT

[GRAY]
[BLACK]
(F)-(E)
C-05
[GRAY]
VEHICLE SPEEDOMETER SENSOR
[WLT] 0922-104 4 2
[GRAY]
MAIN FUSE BLOCK 3 VEHICLE SPEEDOMETER SENSOR
(REFER TO 00F SECTION) INSTRUMENT CLUSTER
F-01 0922-104 4 4
0922-101
[BLACK]
KEY REMINDER SWITCH IGNITION KEY ILLUMINATION
0922-102 0922-103
C-03
(F)-(R)
C-03
(F)-(R)
F-02
FUSE BLOCK
0922-105 C-01
WATER TEMPERATURE ENGINE SWITCH WL-C, WE-C, WLT
SENDER UNIT IGNITION SWITCH G6

22 INSTRUMENTATION/DRIVER INFO. 0922-1a
INSTRUMENT CLUSTER 0922-1b
140
BRAKE FLUID LEVEL SENSOR

0922-110
141
INSTRUMENT CLUSTER
0922-101
4
(F)-SHORT CORD
0922-108
5
PARKING BRAKE SWITCH
0922-109

22 INSTRUMENTATION/DRIVER INFO. 0922-1b
INSTRUMENT CLUSTER 0922-1c
142
INSTRUMENT CLUSTER
0922-101
5
143

22 INSTRUMENTATION/DRIVER INFO. 0922-1c
INSTRUMENT CLUSTER 0922-1d
144
INSTRUMENT CLUSTER
0922-101
145

22 INSTRUMENTATION/DRIVER INFO. 0922-1d
INSTRUMENT CLUSTER 0922-1e
146
[GRAY]
SEDIMENTOR SWITCH
[BLACK]
[BLACK] 0922-112 (F)-(E)
(F)-(E)
C-05
C-05
[WL-C, WE-C]
[G6]
(R)-(DR3)
C-15 0922-111
OIL PRESSURE SWITCH
0922-111 13
147
OIL PRESSURE SWITCH
BUCKLE SWITCH
0922-114
[GRAY]
SEDIMENTOR SWITCH
0922-112
INSTRUMENT CLUSTER
[GRAY]
(F)-(E) 0922-101
C-06 4
5
[WLT]
C-02
(F)-(R)
C-03
(F)-(R)
C-03
C-02 (F)-(R)
(F)-(R)
0922-111
OIL PRESSURE SWITCH

22 INSTRUMENTATION/DRIVER INFO. 0922-1e
0922-2
HORN
148
MAIN FUSE BLOCK

F-01
HORN RELAY
0922-201
0922-203
HORN RH
149
SHORT CONNECTOR
0922-202 0810-102
HORN LH
0922-204
HORN SWITCH
0919-01
HORN SWITCH
[BLACK]
F-02
FUSE BLOCK

22 INSTRUMENTATION/DRIVER INFO. 0922-2
ALPHABETICAL INDEX
4 ELECTRICAL WIRING SCHEMATIC......................18

4X4 CONTROL MODULE ...................................... 72 ENGINE COOLANT
4X4 INDICATOR SWITCH ............................... 68, 70 TEMPERATURE SENSOR ................48, 52, 56, 62
4X4 RELAY ............................................................ 72
4X4 SWITCH .......................................................... 74 F
FICD SOLENOID VALVE ..................................52, 56
A
A/C AMPLIFIER...................................................... 86 FILAMENT...............................................................92
A/C RELAY............................................................. 86 FLASHER CONTROL MODULE ...........................118
A/C SWITCH .......................................................... 86 FOG LIGHT ...........................................................116
ABBREVIATION ..................................................... 12 FOG LIGHT RELAY ..............................................116
ABS HU/CM ........................................................... 76 FOG LIGHT SWITCH ............................................116
ABS WHEEL-SPEED SENSOR ............................. 76 FREE SOLENOID ...................................................72
ACCELERATOR PEDAL FRONT FOG LIGHT..............................................116
POSITION SENSOR ........................................... 50 FRONT FOG LIGHT RELAY .................................116
ACCESSORY SOCKET ....................................... 132 FRONT FOG LIGHT SWITCH ..............................116
AIR BAG MODULE................................................. 88 FRONT POWER WINDOW REGULATOR .............94
AT DIODE............................................................... 78 FRONT SIDE TURN LIGHT ..................................118
AT RELAY .............................................................. 78
FRONT SPEAKER ................................................134
AUDIO UNIT......................................................... 134
AUXILIARY JACK................................................. 136 FRONT TURN LIGHT ...........................................118
FUEL CUT VALVE ..................................................52
B FUEL GAUGE SENDER UNIT..............................138
BACK-UP LIGHT .................................................. 120 FUEL INJECTOR ..............................................44, 62
BACK-UP LIGHT SWITCH................................... 120 FUEL METERING VALVE.......................................44
BLOWER MOTOR.................................................. 86 FUEL PRESSURE SENSOR ..................................46
BLOWER RELAY ................................................... 86 FUEL PUMP............................................................36
BLOWER UNIT....................................................... 86 FUEL PUMP RELAY ...............................................36
BONNET SWITCH ............................................... 108 FUEL TEMPERATURE SENSOR ...........................48
BOOST SENSOR................................................... 48
FUSE BOX ..............................................................20
BRAKE FLUID LEVEL SENSOR.......................... 140
BRAKE LIGHT...................................................... 122
BRAKE SWITCH .................................................. 122 G
BUCKLE SWITCH ................................................ 146 G SENSOR .............................................................76
GENERAL INFORMATION .......................................2
C GENERATOR..........................................................38
CAMSHAFT POSITION SENSOR ................... 46, 60 GLOVE COMPARTMENT LIGHT .........................126
CHECK CONNECTOR........................................... 72 GLOW PLUG...............................................42, 52, 56
GLOW PLUG RELAY ..................................42, 52, 56
CIGARETTE LIGHTER ........................................ 132
GROUND POINT ....................................................28
CKP SENSOR .................................................. 52, 56
CLIMATE CONTROL UNIT .................................... 86
CLOCK SPRING ............................................ 88, 148 H
CLUTCH COIL........................................................ 74 HAZARD WARNING SWITCH ..............................118
CLUTCH PEDAL POSITION SWITCH................... 42 HEADLIGHT..........................................................112
CLUTCH SWITCH.................................................. 64 HEADLIGHT RELAY .............................................112
COIL ..................................................................... 106 HEADLIGHT SWITCH...........................................112
COMMON CONNECTOR LIST .............................. 22 HIGH-MOUNT BRAKE LIGHT ..............................122
CONDENSER......................................................... 60 HORN....................................................................148
CRANKSHAFT POSITION SENSOR..................... 48 HORN RELAY .......................................................148
CTP SWITCH ......................................................... 64 HORN SWITCH.....................................................148
D
DATA LINK CONNECTOR..................................... 32 I
DATA LINK CONNECTOR-2.................................. 34 IAC VALVE ..............................................................62
DIGITAL TRANSMISSION IDLE SWITCH .........................................................48
RANGE SENSOR............................ 40, 74, 84, 120 IGNITER ..................................................................60
DOOR KEY CYLINDER SWITCH ........................ 108 IGNITION COIL .......................................................60
DOOR LOCK ACTUATOR ................................... 102 ILLUMINATION
DOOR LOCK CONTROL MODULE ..................... 100 4X4 SWITCH ......................................................124
DOOR LOCK-LINK SWITCH........................ 100, 110 A/C SWITCH ......................................................126
DOOR SWITCH.................................................... 128 AUDIO UNIT.......................................................124
DRIVER-SIDE AIR BAG MODULE ........................ 88 CONSOLE..........................................................126
DRIVER-SIDE PRE-TENSIONER SEAT BELT ..... 90 HAZARD WARNING SWITCH ...........................124
DRIVER-SIDE SIDE AIR BAG MODULE ............... 90
HEATER CONTROL ..........................................124
DRIVER-SIDE SIDE AIR BAG SENSOR ............... 90
IGNITION KEY ...................................................138
E INSTRUMENT CLUSTER ..................................124
EGR CONTROL SOLENOID VALVE ..................... 46 O/D OFF SWITCH..............................................124
EGR SOLENOID VALVE.................................. 46, 58 REAR WINDOW DEFROSTER SWITCH ..........124
EGR VALVE POSITION SENSOR......................... 46 RFW MAIN SWITCH ..........................................126
150 Revised 12/2010 (Ref. No. L088/10)

ALPHABETICAL INDEX
IMMOBILIZER UNIT ............................................. 106 S
INJECTION PUMP.......................................... 56, 106 SAS CONTROL MODULE...................................... 88
INSTRUMENT CLUSTER..................................... 138 SEDIMENTOR SWITCH....................................... 146
INTAKE AIR TEMPERATURE SIDE AIR BAG MODULE ....................................... 90
SENSOR.................................................. 44, 48, 62 SIDE AIR BAG SENSOR........................................ 90
INTAKE SHUTTER SOLENOID VALVE................. 44 SIDE TURN LIGHT............................................... 118
INTERIOR LIGHT ................................................. 128 SOLENOID BODY .................................................. 82
INTERMEDIATE SHAFT SPEED SENSOR ........... 80 SPEAKER
(FRONT) ............................................................ 134
K (REAR) .............................................................. 136
KEY REMINDER SWITCH ................................... 138 SPEED SENSOR ................................................... 74
KEYLESS CONTROL MODULE........................... 104 STARTER ............................................................... 40
STARTER RELAY .................................................. 40
L
LICENSE PLATE LIGHT ...................................... 114 T
LOCK SOLENOID .................................................. 72 TAILLIGHT............................................................ 114
TCM ........................................................................ 78
M THEFT-DETERRENT CONTROL MODULE ........ 108
MAGNETIC CLUTCH ............................................. 86 THEFT-DETERRENT HORN ............................... 110
MAIN RELAY .................................................... 42, 60 THEFT-DETERRENT HORN RELAY................... 110
MASS AIR FLOW SENSOR ............................. 44, 62 THROTTLE POSITION SENSOR .......................... 62
MOTOR COMPONENT .......................................... 74 TNS RELAY.......................................................... 112
TRANSFER NEUTRAL SWITCH ..................... 68, 70
N TURBINE SHAFT SPEED SENSOR...................... 80
NEUTRAL SWITCH .......................................... 42, 64 TURN LIGHT ........................................................ 118
TURN SWITCH..................................................... 118
O TWEETER ............................................................ 134
O/D OFF SWITCH .................................................. 78
OIL PRESSURE SWITCH .................................... 146 V
OUTPUT SHAFT SPEED SENSOR ....................... 84 VARIABLE BOOST CONTROL
OXYGEN SENSOR ................................................ 62 SOLENOID VALVE.............................................. 46
VARIABLE SWIRL CONTROL
P SOLENOID VALVE.............................................. 46
PANEL LIGHT CONTROL SWITCH..................... 126 VEHICLE IDENTIFICATION NUMBERS (VIN) ........ 3
PARKING BRAKE SWITCH ................................. 140 VEHICLE SPEEDOMETER SENSOR.................. 138
PARKING LIGHT .................................................. 114
PASSENGER-SIDE AIR BAG MODULE ................ 88 W
PASSENGER-SIDE PRE-TENSIONER WATER TEMPERATURE
SEAT BELT ......................................................... 90 SENDER UNIT .................................................. 138
PASSENGER-SIDE SIDE AIR BAG MODULE....... 90 WINDOW DEFROSTER RELAY ............................ 92
PASSENGER-SIDE SIDE AIR BAG SENSOR....... 90 WINDOW DEFROSTER SWITCH.......................... 92
PCM ................................................ 42, 52, 56, 60, 66 WINDSHIELD WASHER MOTOR ........................ 130
POWER OUTER MIRROR ..................................... 98 WINDSHIELD WIPER AND
WASHER SWITCH............................................ 130
POWER OUTER MIRROR SWITCH ...................... 98
WINDSHIELD WIPER MOTOR ............................ 130
POWER STEERING PRESSURE SWITCH ........... 64
WIRING COLOR CODE ........................................... 9
POWER WINDOW MAIN SWITCH ........................ 94
POWER WINDOW REGULATOR
(FRONT) .............................................................. 94
(REAR) ................................................................ 96
POWER WINDOW SUBSWITCH ........................... 94
PRC SOLENOID VALVE ........................................ 62
PRE-TENSIONER SEAT BELT .............................. 90
PURGE SOLENOID VALVE ................................... 62
R
REAR POWER WINDOW REGULATOR ............... 96
REAR SPEAKER .................................................. 136
REAR TURN LIGHT ............................................. 118
REAR WINDOW DEFROSTER RELAY ................. 92
REAR WINDOW DEFROSTER SWITCH............... 92
REFRIGERANT PRESSURE SWITCH .................. 86
RESISTOR ............................................................. 86
RFW CONTROL MODULE..................................... 70
RFW FREE SOLENOID.................................... 66, 70
RFW LOCK SOLENOID ................................... 66, 70
RFW MAIN SWITCH......................................... 66, 70
RFW SWITCH................................................... 68, 70
151

BT50 - Uny0 4 PDF

Uploaded by

Copyright:

Available Formats

BT50 - Uny0 4 PDF

Uploaded by

Document Information

Original Title

Copyright

Available Formats

Share this document

Share or Embed Document

Sharing Options

Did you find this document useful?

Is this content inappropriate?

Copyright:

Available Formats

BT50 - Uny0 4 PDF

Uploaded by

Copyright:

Available Formats

What are the main sections covered in the manual?

What are the main sections covered in the manual?

What safety procedures are emphasized?

What safety procedures are emphasized?

WARNING

Servicing a vehicle can be dangerous. If you have not received

This manual contains “Warnings” and “Cautions” applicable to

The procedures recommended and described in this manual are

The contents of this manual, including drawings and

Parts should be replaced with genuine Mazda replacement parts

Mazda Motor Corporation is not responsible for any problems

Form No. 5753-1A-08E

For proper repair and maintenance, a thorough

All rights reserved. No part of this book may be

© 2008 Mazda Motor Corporation

Form No. 5753-1A-08E

Mazda BT-50 Wiring Diagram (5753-10-08F) (5753-1A-08E)

VEHICLE IDENTIFICATION NUMBERS (VIN)

Revised 9/2008 (Ref. No. L081/08)

Form No. 5753-1A-08E

00 GENERAL INFORMATION 08 RESTRAINTS

Form No. 5753-1A-08E

for General (L.H.D. R.H.D.) Model year 9= 2009 A=2010, B=2011...

for Australia No meaning 0

Minor change code 4

Body style Y0= Long

Carline, Series UN= Mazda BT-50

MM0= MAZDA (Australia)

Form No. 5753-1A-08E

Mazda BT-50 Wiring Diagram (5753-10-08F) (5753-1A-08E)

3 Revised 9/2008 (Ref. No. L081/08)

Form No. 5753-1A-08E

R Reading wiring diagrams

Depending on the vehicle model, the actual sections may be different.

Form No. 5753-1A-08E

B(F) B(EM) 5 B(D)

The ground connection numbers in system circuit diagrams

T S F-04 G C-06 J-04 10A 14 J-01 C-03

Form No. 5753-1A-08E

F-03 F-03 F-04

F-01 F-03 LG BR/B

F: Fuse box connectors B 23 22

J: Joint box/Junction box connectors B

D: Data link connector 5

0119: Starting system connectors 0140-103

0212: Wheel and tires connectors

Form No. 5753-1A-08E

BOOST SENSOR • Male and female connectors are represented as follows

Solid color wire Striped wire

Form No. 5753-1A-08E

Connector symbol Component name Ground symbol

System connectors 0922-05

HARNESS SYMBOL : (F) (E) (R)

Form No. 5753-1A-08E

DESCRIPTION OF HARNESS SYMBOL DESCRIPTION OF HARNESS SYMBOL

WIRING COLOR CODE

COLOR CODE COLOR CODE

Form No. 5753-1A-08E

Symbol Meaning Symbol Meaning