Sist Eléctrico 420F2

UENR5149-01
January 2018
UENR5149-01 VOL 1 of 3
(Dimensions: 56 inches x 35 inches)
420F2, 428F2, 430F2, 432F2,
434F2 and 444F2 Backhoe Loader
Electrical System
420F2: 428F2: 430F2: 432F2:
LYB1-546 LYG1-1833 LYD1-194 LYJ1-582
LYC1-444 LYE1-202
LBS1-457
42 Page,
434F2: 444F2:
LYK1-328 LYL1-360
Volume 1 of 3: Cab
© 2018 Caterpillar, All Rights Reserved Printed in U.S.A.
Harness And Wire Electrical Schematic Symbols

CONN 8 14 Symbols
30
T
Pressure Temperature Level Flow Circuit Breaker

10 11 15 Symbol Symbol Symbol Symbol Symbol
18
Symbols and Definitions
22 Fuse: A component in an electrical circuit that will open the circuit if too much current flows
through it.
Component Location Switch (Normally Open): A switch that will close at a specified point (temp, press, etc.). The
circle indicates that the component has screw terminals and a wire can be disconnected from it.
Com ponent
Schem atic Machine
Com ponent
Schem atic Machine 12
Location Location Location Location Switch (Normally Closed): A switch that will open at a specified point (temp, press, etc.).
No circle indicates that the wire cannot be disconnected from the component.
Base - Loader Joystick C-8 1 Port - Pow er F-16 20
Board - Pow er Distribution J-3 2 Resistor - CAN Data Link 1 I-16 21
32 13 Ground (Wired): This indicates that the component is connected to a grounded wire. The
grounded wire is fastened to the machine.
Control - FNR Autoshift F-10 3 Resistor - CAN Data Link 2 C-11 22
Ground (Case): This indicates that the component does not have a wire connected to ground.
Control - FNR Manual F-11 4 Solenoid - Hoe Aux Valve 2 #1 F-16 23 It is grounded by being fastened to the machine.
Diode - Washer D-10 5 Solenoid - Hoe Aux Valve 2 #2 F-16 24 1 Reed Switch: A switch whose contacts are controlled by a magnet. A magnet closes the
ECM - Machine J-8 6 Sw itch - Auto/Man F-9 25 contacts of a normally open reed switch; it opens the contacts of a normally closed reed switch.
Ground - Control G-7 7 Sw itch - AWD H-9 26 Sender: A component that is used with a temperature or pressure gauge. The sender
Ground - ECM Cab E-9 8 Sw itch - LH Brake I-10 27 5 2 8 T
measures the temperature or pressure. Its resistance changes to give an indication to
the gauge of the temperature or pressure.
Ground - Low er Cab G-7 9 Sw itch - Loader Lock H-9 28
Relay (Magnetic Switch): A relay is an electrical component that is activated by electricity.
Handle - LH Operator 1 H-16 10 Sw itch - Multi Function Column E-10 29 It has a coil that makes an electromagnet when current flows through it. The
electromagnet can open or close the switch part of the relay.
Handle - LH Operator 2 G-16 11 Sw itch - Parking Brake E-16 30
Joystick - Mech Loader B-8 12 Sw itch - Rear Fog Lamp I-9 31 Solenoid: A solenoid is an electrical component that is activated by electricity. It has a
Joystick - Pilot Loader B-8 13 Sw itch - Return To Dig (PL) D-8 32 CONN 7 coil that makes an electromagnet when current flows through it. The electromagnet
can open or close a valve or move a piece of metal that can do work.
Keypad - Antitheft D-16 14 Sw itch - RH Brake I-10 33
Motor - Air Seat B-4 15 Sw itch - Ride Control G-9 34 CONN 14 Magnetic Latch Solenoid: A magnetic latch solenoid is an electrical component that is
activated by electricity and held latched by a permanent magnet. It has two coils (latch and unlatch)
that make electromagnet when current flows through them. It also has an internal switch that places
Motor - Front Washer D-10 16 Sw itch - Ride Control LL G-9 35 the latch coil circuit open at the time the coil latches.
Motor - Front Wiper D-10 17 Sw itch - Roading G-9 36
7 Harness and Wire Symbols
Motor - Heated Air Seat B-3 18 Sw itch - Transmission Handle Neutral B-4 37
6 Wire, Cable, or Harness Harness Identification Letter(s):
Motor - Rear Washer D-10 19 Sw itch - Transmission Lock I-9 38 Assembly Identification: Includes (A, B, C, ..., AA, AB, AC, ...)
16 CONN 16 CONN 12 Harness Identification Letters and

Harness Connector Serialization
Harness Connector Serialization Code:
The "C" stands for "Connector" and the
19 Codes (see sample).
number indicates which connector in the
CONN 9 CONN 15 AG-C4 L-C12 L-C12

harness (C1, C2, C3, ...).
21 111-7898 3E-5179 3E-5179

CONN 11 Part Number: for Connector Plug 1
Part Number: for Connector Receptacle
9 2
Plug Receptacle
Pin or Socket Number
CONN 19 37 1 Deutsch connector: Typical representation
5A
Component
of a Deutsch connector. The plug contains all Fuse (5 Amps) 9X-1123 Part Number
*37 NOT SHOWN 2 sockets and the receptacle contains all pins.
CONN 18 Sure-Seal connector: Typical representation
325-AG135 PK-14
CONN 17 1
of a Sure-Seal connector. The plug and receptacle
Harness identification code:
Wire Gauge
CONN 13 2 contain both pins and sockets.
This example indicates wire group 325,
wire 135 in harness "AG". Wire Color
CONN 20
RH CAB/CHASSIS VIEW CAB INTERIOR VIEW
CONN 21
27
17
38
Connector Location
Schem atic
Connector Num ber
Location 26
CONN 1 J-16
23
CONN 2 I-16
CONN 3 H-16
CONN 4 H-16 33 20
CONN 5 G-16, G-15
CONN 6 E-16
CONN 7 D-16
CONN 8 B-16
24
CONN 9 C-11 3 36
CONN 10 C-11
CONN 11 C-11
CONN 12 F-11
4 31
CONN 13 J-11
CONN 14 B-9 CONN 6
CONN 15 C-9 *CONN 6 LOCATED
CONN 16 D-8, C-8 BEHIND PANEL
CONN 17 B-5 VIEW OF AREA “A”
CONN 18 C-5 (ROTATED FOR CLARITY)
CONN 19 E-5 28 CONN 1
CONN 20 E-5 CONN 2
CONN 21 F-5
34 CONN 3
The connectors show n in this chart are for harness to
harness connectors. Connectors that join a harness to a CONN 4
component are generally located at or near the 35 A
component. See the Component Location Chart. CONN 5
25 CONN 10
29
FRONT DASH VIEW RH CAB/VALVE VIEW

16 15 14 13 12 11 10 9 8 7 6 5 4 3 2 1
PL-C26
3313595
1 997-PL304 OR- 0.75
2 605-PL365 YL - 0.75
3 606-PL366 GY- 0.75
4 617-PL125 BR - 0.75
5 367-PL379 BU - 0.75
6 T993-PL48 BR - 0.75
7 M963-PL170 BU - 0.75
8 604-PL367 OR- 0.75
J CONN 1
9
10
R762-PL81
R763-PL80
GY- 1.00
BU - 1.00
J
CONNECTS TO RT-C1 11 G962-PL177 OR- 0.75
VOL 2 LOC I-13 12 A305-PL137 YL - 0.75
OR 13 200-PL303 BK - 2.00
CONNECTS TO RN-C1
14 M962-PL269 YL - 0.75
15 H802-PL220 GY- 0.75

VOL 3 LOC C-6 16 321-PL103 BR - 0.75
OR 17
CONNECTS TO RJ-C1 18
VOL 3 LOC F-6 19 PL-C29
20 T969-PL221 YL - 0.75 3463497 H1 (2) POWER DISTRIBUTION BOARD H1
(6) MACHINE ECM
21 T970-PL399 GY- 0.75 611-PL319 PU - 1.00 A
464-2924 PL-C31 123-PL262 WH- 1.00 438-9069
22 T971-PL222 OR- 0.75 200-PL290 BK - 2.00 B CONN 13 J1 3748331
23 T972-PL148 GN- 0.75 619-PL310 GN- 1.00 C CONNECTS TO FL-C1 PWM RTN: DRVR: 1, 3, 4, 5 1 H801-PL201 PU - 0.75 126-PL197 RD- 2.00 126-PL197 RD- 2.00 131-PL421 BR - 1.00
24 E747-PL259 BK - 0.75 102-PL1 RD- 2.00 617-PL338 BR - 0.75 D VOL 2 LOC B-5 627-PL374 YL - 0.75 XMSN FWD CLUTCH (PWM DRVR 1) 2 752-PL211 YL - 0.75 126-PL203 RD- 2.00 126-PL203 RD- 2.00 118-PL388 GY- 2.00
25 H801-PL117 PU - 0.75 102-PL17 RD- 2.00 605-PL89 YL - 0.75 E 614-PL409 PU - 0.75 3 126-PL204 RD- 2.00 126-PL204 RD- 2.00 122-PL416 BU - 3.00
26 E543-PL214 WH- 0.75 102-PL1 RD- 2.00 111-PL73 RD- 0.75 XMSN REV CLUTCH (PWM DRVR 2) 4 754-PL212 BU - 0.75 202-PL187 BK - 2.00 202-PL187 BK - 2.00 123-PL397 WH- 1.00
27 E544-PL215 GN- 0.75 8 1 3 4 6 10 K8 K27
111-PL74 RD- 0.75 BACK UP ALARM (FAST DECAY SOURCING DRVR 1) 5 331-PL41 OR- 0.75 202-PL191 BK - 2.00 202-PL191 BK - 2.00 123-PL420 WH- 1.00 X6 STUD
28 C216-PL250 BK - 0.75 102-PL17 RD- 2.00 111-PL130 RD- 0.75 DIFF LOCK SOLENOID (FAST DECAY SOURCING DRVR 2) 6 324-PL19 BU - 1.00 202-PL216 BK - 2.00 202-PL216 BK - 2.00 133-PL84 OR- 0.75 DCU KEEP-ALIVE
29 618-PL384 YL - 0.75 X1 STUD
111-PL158 RD- 0.75 (31) REAR FOG LAMP SWITCH IMPLEMENT LOCK OUT SOLENOID (ON/OFF SOURCING DRVR 1) 7 G962-PL177 OR- 0.75 324-PL19 BU - 1.00 324-PL19 BU - 1.00 200-PL303 BK - 2.00 BATTERY + POWER
NOT NOT
30 627-PL374 YL - 0.75 105-PL150 RD- 0.75 105-PL150 RD- 0.75 118-PL368 GY- 2.00 387-6557 XMSN SPEED CLUTCH 3 (ON/OFF SOURCING DRVR 2) 8 902-PL232 BR - 0.75 331-PL41 OR- 0.75 331-PL41 OR- 0.75 FITTED MINI FITTED X4 STUD
MAXI
31 H771-PL145 BR - 1.00 118-PL383 GY- 2.00 PL-C69 XMSN SPEED CLUTCH 1 (ON/OFF SOURCING DRVR 3) 9 751-PL230 GN- 0.75 404-PL245 YL - 0.75 404-PL245 YL - 0.75 200-PL322 BK - 2.00 C568-PL418 WH- 3.00
PL-C8
111-PL73 RD- 0.75 123-PL354 WH- 1.00 7 2 5 9 2285856 LOADER AUX VALVE PORT A SOL (PWM DRVR 3) 10 E543-PL214 WH- 0.75 405-PL253 GY- 0.75 405-PL253 GY- 0.75 F1 RATING : C568-PL419 WH- 3.00
1082253 30A (C4.4 HRC ENGINE)
111-PL74 RD- 0.75 131-PL7 BR - 1.00 11 420-PL264 OR- 0.75 420-PL264 OR- 0.75 200-PL381 BK - 3.00 60A (C3.4 HRC ENGINE)
LOW / MED BLOWER X5 STUD
111-PL130 RD- 0.75 136-PL357 GN- 1.00 604-PL71 OR- 0.75 A (27) LH BRAKE SWITCH 202-PL410 BK - 0.75 12 439-PL266 YL - 0.75 439-PL266 YL - 0.75 DCU F43 40A F4 20A 122-PL416 BU - 3.00
111-PL158 RD- 0.75 143-PL404 BR - 1.00 C789-PL106 YL - 0.75 B
105-8034 610-PL385 OR- 1.00 SOURCING RTN: XMSN SPEED CLUTCH 1, 3 13 975-PL229 WH- 0.75 442-PL195 GY- 0.75 442-PL195 GY- 0.75 202-PL345 BK - 1.00 F1 A
111-PL241 RD- 1.00 200-PL3 BK - 0.75 111-PL73 RD- 0.75 C NOTE E SOURCING RTN: BACK UP ALARM 14 E747-PL249 BK - 0.75 568-PL236 GN- 0.75 568-PL236 GN- 0.75 START F2 30A F44 25A
X2 STUD X7 STUD
200-PL12 BK - 0.75 SOURCING RTN: IMPLEMENT LOCKOUT 15 C216-PL250 BK - 0.75 585-PL199 YL - 0.75 585-PL199 YL - 0.75 202-PL414 BK - 1.00 KEEP-ALIVE 384-PL13 BU - 3.00
115-PL173 RD- 1.00 115-PL190 RD- 1.00 200-PL23 BK - 0.75 708-PL208 YL - 0.75 RIDE CTRL/LOAD CHECK ENABLE RELAY (SINKING DRVR 1) 16 F738-PL233 WH- 0.75 751-PL230 GN- 0.75 751-PL230 GN- 0.75 310-PL295 PU - 0.75 X21 HVAC F3 50A 384-PL68 BU - 3.00
PL-C7
115-PL351 RD- 1.00 200-PL76 BK - 0.75 C720-PL271 BU - 0.75 17 752-PL211 YL - 0.75 752-PL211 YL - 0.75 314-PL260 PU - 3.00 FUSE PAD TO TEST H1
1082253 ATO AND MAXI FUSE
200-PL104 BK - 0.75 614-PL313 PU - 0.75 18 754-PL212 BU - 0.75 754-PL212 BU - 0.75 320-PL166 OR- 0.75
118-PL368 GY- 2.00 200-PL175 BK- 0.75 604-PL72 OR- 0.75 (33) RH BRAKE SWITCH 900-PL228 PU - 0.75 900-PL228 PU - 0.75 321-PL103 BR - 0.75
CONN 2 PL-C34
A
105-8034 8 1 3 4 6 10
19 NON-CARB
LINK
A R1
200-PL32 BK - 0.75 118-PL383 GY- 2.00 200-PL202 BK- 0.75 720-PL123 PU - 0.75 B 20 902-PL232 BR - 0.75 902-PL232 BR - 0.75 322-PL294 GY- 0.75
CONNECTS TO RT-C13 2458025 NOTE E
200-PL143 BK - 0.75 118-PL388 GY- 2.00 200-PL290 BK - 2.00 111-PL74 RD- 0.75 C DIGITAL RTN - STAB SENSOR, RC SENSOR, PUMP PRESS SENSOR, FNR 21 J764-PL97 BR - 0.75 903-PL231 GY- 0.75 903-PL231 GY- 0.75 367-PL379 BU - 0.75 K6
VOL 2 LOC H-13 1 M948-PL107 BR - 0.75 200-PL303 BK - 2.00 200-PL330 BK- 1.00 (38) TRANSMISSION LOCK SWITCH ANALOGUE RTN: THUMB ROLLER - LOADER, REAR LH AND RH AUX 22 T993-PL102 BR - 0.75 975-PL229 WH- 0.75 975-PL229 WH- 0.75 384-PL13 BU - 3.00 PL-C14 GLOW PLUGS
I OR 2 M947-PL119 OR- 0.75 320-PL412 OR- 0.75 123-PL79 WH- 1.00 123-PL79 WH- 1.00 200-PL349 BK - 0.75 387-6527 FUEL ECO MODE LAMP (SINKING DRVR 3) 23 H466-PL56 BU - 0.75 997-PL304 OR- 0.75 997-PL304 OR- 0.75 384-PL68 BU - 3.00 3915148 X8
K5
F36 30A PL-C20
I
86
30
ENGINE
CONNECTS TO RN-C15 3 A122-PL309 YL - 0.75 321-PL103 BR - 0.75 123-PL354 WH- 1.00 200-PL350 BK - 0.75 PL-C55 ACTION LAMP (SINKING DRVR 2) 24 F420-PL225 GN- 0.75 518-PL44 OR- 1.00 1 ENG SNSR X12 3915139
86
30
IGN 1
VOL 3 LOC B-6 4 T907-PL178 GN- 0.75 367-PL379 BU - 0.75 200-PL353 BK - 2.00 PL-C33 7 2 5 9 2285856 J1939 CAN A HIGH (+) 25 F711-PL276 YL - 0.75 A122-PL226 YL - 0.75 A122-PL226 YL - 0.75 519-PL15 PK - 0.75 105-PL60 RD- 1.00 2 KEY F30 10A F23 10A 1
3785571 MAXI
OR 5 X800-PL373 OR- 0.75 604-PL367 OR- 0.75 131-PL7 BR - 1.00 131-PL7 BR - 1.00 202-PL18 BK - 0.75 J1939 CAN A LOW (-) 26 F712-PL277 GN- 0.75 C216-PL250 BK - 0.75 C216-PL250 BK - 0.75 521-PL307 YL - 0.75 136-PL357 GN- 1.00 3 AWS F32 10A ENG ECM 1 2
MAXI
6 J764-PL263 BR - 0.75 605-PL365 YL - 0.75 136-PL357 GN- 1.00 136-PL357 GN- 1.00 202-PL43 BK - 0.75 604-PL146 OR- 0.75 1 202-PL52 BK- 0.75 27 E455-PL246 BR - 0.75 E455-PL246 BR - 0.75 537-PL318 GN- 0.75 125-PL378 RD- 0.75 4 TELEMATICS F29 10A F35 20A 3
87A
CONNECTS TO RJ-C2
87
85
606-PL366 GY- 0.75 143-PL404 BR - 1.00 143-PL404 BR - 1.00 C789-PL152 YL - 0.75 2 308-PL312 YL - 0.75 28 E543-PL214 WH- 0.75 E543-PL214 WH- 0.75 601-PL42 GY- 2.00 5 SPARE USB F40 15A ENG ECM 2 4 123-PL420 WH- 1.00
87A
VOL 3 LOC E-6 NOT CONNECTED
87
85
617-PL125 BR - 0.75 161-PL30 RD- 1.00 161-PL30 RD- 1.00 202-PL161 BK - 1.00 3 J878-PL332 YL - 0.75 PWM RTN: DRVR 6, 7, 8, 9 29 H802-PL111 GY- 0.75 E544-PL215 GN- 0.75 E544-PL215 GN- 0.75 607-PL129 PK - 1.00 6 F22 10A 5
618-PL384 YL - 0.75 200-PL3 BK - 0.75 200-PL3 BK - 0.75 202-PL164 BK - 0.75 111-PL130 RD- 0.75 4 30 E711-PL273 OR- 0.75 E711-PL273 OR- 0.75 607-PL325 PK - 1.00 106-PL169 RD- 0.75 7 INST CLUSTER F28 10A 6
627-PL374 YL - 0.75 200-PL12 BK - 0.75 START RELAY (SINKING DRVR 5) 31 H735-PL180 GY- 0.75 E747-PL249 BK - 0.75 E747-PL249 BK - 0.75 608-PL153 GN- 1.00 126-PL204 RD- 2.00 8 ECM F31 25A 7 310-PL295 PU - 0.75
997-PL304 OR- 0.75 202-PL165 BK - 0.75 TRANSMISSION LOCKOUT SWITCH ACTION ALARM (SINKING DRVR 4) 32 568-PL236 GN- 0.75 E900-PL182 WH- 0.75 E900-PL182 WH- 0.75 608-PL268 GN- 1.00 H1 126-PL203 RD- 2.00 9 JHKJH c13
c4
F34 20A FRONT WIPER 8 118-PL388 GY- 2.00

K10
200-PL23 BK - 0.75 200-PL23 BK - 0.75 PL-C28 STATUS SWITCH POS CONNECTS XMSN STATE 33 E901-PL183 GN- 0.75 E901-PL183 GN- 0.75 111-PL241 RD- 1.00 10 BRAKE LAMP F27 10A 9
3785571 K4
A122-PL309 YL - 0.75 200-PL104 BK - 0.75 202-PL345 BK - 1.00 OFF UNLOCK 4&5 ENABLED 34 E917-PL224 WH- 0.75 E917-PL224 WH- 0.75 A305-PL53 YL - 0.75 11
A122-PL361 YL - 0.75 308-PL25 YL - 0.75 604-PL184 OR- 0.75 1 RIDE CONTROL SENSOR (FREQ / PWM INPUT 1) 35 976-PL98 OR- 0.75 E918-PL223 GN- 0.75 E918-PL223 GN- 0.75 C510-PL11 WH- 0.75 126-PL197 RD- 2.00 12 PL-C25
86
30
PL-C41 ON LOCK 2&3 AND 5&6 DISABLED IGN 2 CARB K14 3500477
2698222 A305-PL137 YL - 0.75 308-PL109 YL - 0.75 720-PL234 PU - 0.75 2
NOT CONNECTED RTN FOR ALL SWG SWITCHES 36 F420-PL225 GN- 0.75 F738-PL233 WH- 0.75 C568-PL418 WH- 3.00 115-PL190 RD- 1.00 13 ACC SKT F26 10A SHUTOFF NOT
X13
A305-PL402 YL - 0.75 200-PL290 BK - 2.00 320-PL411 OR- 0.75 3 MAIN HYD PUMP PRESS SNSR (FREQ/PWM INPUT 2) 37 J984-PL36 PK - 0.75 F738-PL233 WH- 0.75 F420-PL225 GN - 0.75 C568-PL419 WH- 3.00 X977-PL422 YL - 1.00 14 FITTED SPARE
SERVICE PORT CONN X17 1
A F711-PL77 YL - 0.75 A305-PL413 YL - 0.75 200-PL240 BK - 2.00 200-PL353 BK - 2.00 453-PL274 PK - 0.75 111-PL158 RD- 0.75 552-PL8 WH- 0.75 F761-PL45 BR - 0.75 F761-PL45 BR - 0.75 F711-PL95 YL - 0.75 180-PL261 GN- 2.00 15 20A MAXI MICRO 2
(21) CAN DATA LINK RESISTOR 1 4 38 AIR SEAT F5
NOT
B F712-PL78 GN- 0.75 C216-PL250 BK - 0.75 500-PL394 BR - 1.00 718-PL126 BU - 0.75 G423-PL244 PK - 0.75 G423-PL244 PK - 0.75 F712-PL96 GN- 0.75 161-PL30 RD- 1.00 3
134-2540 39 16 HAZARDS/HLNR F25 15A POWER = A
87A
MICRO FITTED
87
85
C
E543-PL214 WH- 0.75 200-PL330 BK - 1.00 719-PL128 GY- 0.75 HYD FILTER BYPASS (SINKING DRVR 6) 40 G423-PL244 PK - 0.75 G962-PL177 OR- 0.75 G962-PL177 OR- 0.75 F738-PL233 WH- 0.75 17 GND = B 4
E544-PL215 GN- 0.75 501-PL392 GN- 1.00 823-PL131 GN- 0.75 XMSN FNR SIGNAL 1 (PWM INPUT4) 41 G956-PL66 BU - 0.75 H466-PL56 BU - 0.75 H466-PL56 BU - 0.75 G703-PL390 GN- 0.75 18 CDL POS = D 5
E747-PL259 BK - 0.75 200-PL349 BK - 0.75 614-PL314 PU - 0.75 XMSN FNR SIGNAL 2 (PWM INPUT5) 42 H904-PL110 GY- 0.75 H705-PL149 BR - 0.75 H705-PL149 BR - 0.75 N939-PL359 GN- 0.75 P832-PL403 WH- 0.75 19 CDL NEG = E 6 F712-PL96 GN- 0.75
42 Page,
F711-PL77 YL - 0.75 502-PL34 OR- 2.00 IMPLEMENT LOCKOUT SW - LOCKED OUT (SWG INPUT 13) 43 E917-PL224 WH- 0.75 J832-PL326 YL - 0.75 J832-PL326 YL - 0.75 P832-PL282 WH- 0.75 307-PL281 OR- 0.75 20 JHKJH c14
c5
CAN NEG = F 7
F712-PL78 GN- 0.75 200-PL350 BK - 0.75 102-PL1 RD- 2.00 102-PL1 RD- 2.00 8 1 3 4 6 10 HYDRAULIC OIL FILTER BYPASS SW (SWG INPUT 14) 44 E455-PL246 BR - 0.75 J879-PL237 GN- 0.75 J879-PL237 GN- 0.75 P832-PL403 WH- 0.75 515-PL40 GY- 0.75 21 HI FAN SPEED CAN POS = G 8 F711-PL95 YL - 0.75
G962-PL177 OR- 0.75 506-PL116 PU - 0.75 AIR FILTER RESTRICTION SW (SWG INPUT 18) 45 420-PL264 OR- 0.75 J984-PL36 PK - 0.75 J984-PL36 PK - 0.75 F24 10A
K2
9
H771-PL145 BR - 1.00 506-PL160 PU - 0.75 202-PL43 BK - 0.75 202-PL52 BK - 0.75 (26) AWD SWITCH 46 L740-PL188 BR - 0.75 L740-PL188 BR - 0.75 PL-C24 HORNS 10
H801-PL117 PU - 0.75 200-PL76 BK - 0.75 506-PL168 PU - 0.75 202-PL164 BK - 0.75 202-PL88 BK - 0.75 387-6579 ALTERNATOR R-TERMINAL / W-TERMINAL INPUT 47 450-PL238 YL - 0.75 M739-PL35 YL - 0.75 M739-PL35 YL - 0.75 3500479 X9 MAXI 11
86
30
H802-PL159 GY- 0.75 200-PL175 BK - 0.75 507-PL114 WH- 0.75 202-PL165 BK - 0.75 202-PL291 BK - 0.75 PL-C51 HIGH HYD OIL TEMP IND (SINKING DRVR 8) 48 404-PL245 YL - 0.75 M936-PL287 BR - 0.75 M936-PL287 BR - 0.75 307-PL163 OR- 0.75 1 12
PL-C18 H802-PL220 GY- 0.75 200-PL202 BK - 0.75 537-PL283 GN- 0.75 202-PL161 BK - 1.00 202-PL186 BK - 0.75 7 2 5 9 2285856 SOURCING RTN: XMSN SPEED CLUTCH 2 49 M739-PL35 YL - 0.75 M937-PL300 GN- 0.75 M937-PL300 GN- 0.75 331-PL41 OR- 0.75 2 13
2698222 J764-PL263 BR - 0.75 200-PL405 BK - 2.00 552-PL8 WH- 0.75 202-PL289 BK - 0.75 ENGINE OIL PRESS SW (SWG INPUT 10) 50 405-PL253 GY- 0.75 M947-PL196 OR- 0.75 M947-PL196 OR- 0.75 3 14
CONN 3 M719-PL27 GN - 1.00 585-PL199 YL - 0.75 102-PL1 RD- 2.00 202-PL301 BK - 0.75 202-PL88 BK - 0.75 FUEL ECO MODE SW (SWG INPUT 11) 51 E711-PL273 OR- 0.75 M948-PL209 BR - 0.75 M948-PL209 BR - 0.75 4 15
87A
A 200-PL143 BK - 0.75 NEUTRAL
87
85
M721-PL64 WH - 1.00 202-PL18 BK - 0.75 586-PL200 BR - 0.75 202-PL43 BK - 0.75 202-PL410 BK - 0.75 J878-PL162 YL - 0.75 IMPLEMENT LOCKOUT SW - NOT LOCKED OUT (SWG INPUT 12) 52 E918-PL223 GN- 0.75 M962-PL269 YL - 0.75 M962-PL269 YL - 0.75 102-PL1 RD- 2.00 102-PL1 RD- 2.00 307-PL281 OR- 0.75 5 START
CONNECTS TO PE-C1 B M719-PL27 GN- 1.00 K11 NOT
M947-PL119 OR- 0.75 202-PL144 BK - 0.75 202-PL65 BK - 0.75 590-PL142 GY- 2.00 202-PL161 BK - 1.00 J878-PL279 YL - 0.75 LOADER AUX CTRL (THUMB ROLLER) (-) (ANLG INPUT 2) 53 Y974-PL39 BU - 0.75 M963-PL170 BU - 0.75 M963-PL170 BU - 0.75 102-PL17 RD- 2.00 102-PL17 RD- 2.00 6 PL-C67
VOL 2 LOC G-9 C M721-PL64 WH- 1.00 FITTED MICRO
M947-PL124 OR- 0.75 202-PL370 BK - 2.00 202-PL164 BK - 0.75 308-PL285 YL - 0.75 202-PL291 BK - 0.75 54 T907-PL178 GN- 0.75 T907-PL178 GN- 0.75 105-PL60 RD- 1.00 105-PL60 RD- 1.00 308-PL108 YL - 0.75 7 X14 3915149
M948-PL105 BR - 0.75 202-PL161 BK - 1.00 601-PL42 GY- 2.00 202-PL165 BK - 0.75 308-PL109 YL - 0.75 308-PL311 YL - 0.75 55 T969-PL221 YL - 0.75 T969-PL221 YL - 0.75 106-PL169 RD- 0.75 106-PL169 RD- 0.75 307-PL265 OR- 0.75 8 JHKJH c15
c6
1
M948-PL107 BR - 0.75 604-PL71 OR- 0.75 308-PL109 YL - 0.75 308-PL312 YL - 0.75 8V SUPPLY - STAB SENSOR, RIDE CONT SENSOR, PUMP PRESS SENSOR 56 X800-PL408 OR- 0.75 T970-PL217 GY- 0.75 T970-PL217 GY- 0.75 111-PL241 RD- 1.00 111-PL241 RD- 1.00 9 2
M962-PL269 YL - 0.75 202-PL345 BK - 1.00 202-PL345 BK - 1.00 604-PL72 OR- 0.75 552-PL8 WH- 0.75 ALL WHEEL DRIVE (AWD) LOADER AUX VALVE PORT B SOL (PWM DRVR 4) 57 E544-PL215 GN- 0.75 T971-PL222 OR- 0.75 T971-PL222 OR- 0.75 115-PL190 RD- 1.00 115-PL190 RD- 1.00 143-PL138 BR - 1.00 10 IMP DISABLE/CP HYD F6 15A 3
K16
M963-PL170 BU - 0.75 105-PL60 RD- 1.00 307-PL163 OR- 0.75 307-PL163 OR- 0.75 604-PL146 OR- 0.75 601-PL42 GY- 2.00 552-PL8 WH- 0.75 552-PL8 WH- 0.75 AWD STATUS SWITCH POS ECM (J2) QUICK COUPLER SW - DISENGAGE PINS (SWG INPUT 7) 58 586-PL200 BR - 0.75 T972-PL219 GN- 0.75 T972-PL219 GN- 0.75 116-PL257 BR - 1.00 116-PL257 BR- 1.00 121-PL22 YL - 1.00 11 BREATHER HEATER F8 10A D2 4 607-PL325 PK - 1.00
H CONN 4
WIRE AS.
8Y-7833
PL-C70
2458026
R762-PL81 GY- 1.00
R763-PL80 BU - 1.00 105-PL235 RD- 1.00
105-PL150 RD- 0.75
308-PL59 YL - 0.75 308-PL25 YL - 0.75
604-PL184
605-PL89
OR- 0.75
YL - 0.75
610-PL385 OR- 1.00
610-PL393 OR- 2.00
601-PL42 GY- 2.00
610-PL385 OR- 1.00
601-PL42 GY- 2.00
610-PL385 OR- 1.00
OFF LOW PINS: 4
HIGH PINS: 3, 6
LOW PINS: 72
HIGH PINS: 71, 78
LOADER CONT FLOW SW - N/O (SWG INPUT 8)
RIDE CONT ON / DEAD ENG LOWER (SWG INPUT 9)
59
60
852-PL205 GN- 0.75
F748-PL206 WH- 0.75
117-PL258 YL - 1.00
119-PL386 PK - 2.00
117-PL258 YL- 1.00
119-PL386 PK- 2.00 E747-PL63 BK - 0.75
12
13
STAB SENSORS
D7
F11 10A
K3 K13
D3
BACKUP
ALARM
5
6
607-PL129
C510-PL11
PK - 1.00
WH- 0.75 H
T907-PL178 GN- 0.75 105-PL213 RD- 0.75 308-PL417 YL - 0.75 308-PL94 YL - 0.75 605-PL90 YL - 0.75 614-PL218 PU - 0.75 610-PL393 OR- 2.00 610-PL393 OR- 2.00 LOADER AUX CTRL (THUMB ROLLER) (+) (ANLG INPUT 1) 61 Y973-PL57 WH- 0.75 123-PL79 WH- 1.00 123-PL79 WH- 1.00 119-PL386 PK - 2.00 14 REAR WIPER F7 20A MICRO NOTE V 7 601-PL42 GY- 2.00
AWD WITH LOW PINS: 3, 4 LOW PINS: 71, 72
ATTACH WIRE AS. TO PL-C70 1 320-PL412 OR- 0.75 T969-PL221 YL - 0.75 308-PL109 YL - 0.75 605-PL91 YL - 0.75 627-PL374 YL - 0.75 627-PL374 YL - 0.75 627-PL374 YL - 0.75 WATER IN FUEL SENSOR (SWG INPUT 15) 62 439-PL266 YL - 0.75 123-PL262 WH- 1.00 123-PL262 WH- 1.00 117-PL258 YL - 1.00 15 REAR FLOOD ATCH F10 15A HVAC POSITION RELAY 8 133-PL84 OR- 0.75
86
30
86
30
BREAKING HIGH PINS: 6 HIGH PINS: 78 D1
LAMP LINK K15
ON CP MACHINES ONLY BK-18 2 A305-PL413 YL - 0.75 T970-PL399 GY- 0.75 106-PL169 RD- 0.75 106-PL169 RD- 0.75 308-PL108 YL - 0.75 606-PL50 GY- 0.75 63 123-PL354 WH- 1.00 123-PL354 WH- 1.00 121-PL22 YL - 1.00 16 9
T970-PL400 GY- 0.75 115-PL173 RD- 1.00 115-PL173 RD- 1.00 308-PL181 YL - 0.75 606-PL86 GY- 0.75 708-PL208 YL - 0.75 614-PL62 PU - 0.75 ON LOW PINS: 3, 6 LOW PINS: 71, 78 64 123-PL397 WH- 1.00 123-PL397 WH- 1.00 17 SPARE F42 15A 10 608-PL268 GN- 1.00
86
30
MICRO
T971-PL222 OR- 0.75 115-PL351 RD- 1.00 115-PL351 RD- 1.00 606-PL87 GY- 0.75 718-PL126 BU - 0.75 614-PL313 PU - 0.75 HIGH PINS: 4 HIGH PINS: 72 LOCK-UP CLUTCH (PWM DRVR 5) 65 J832-PL326 YL - 0.75 123-PL420 WH- 1.00 123-PL420 WH- 1.00 116-PL257 BR - 1.00 18 REAR FLOOD F9 15A AIR CON 11 608-PL153 GN- 1.00
T972-PL148 GN- 0.75 116-PL257 BR - 1.00 116-PL257 BR - 1.00 320-PL166 OR- 0.75 610-PL115 OR- 2.00 719-PL128 GY- 0.75 614-PL218 PU - 0.75 614-PL314 PU - 0.75 66 124-PL306 GN- 0.75 124-PL306 GN- 0.75 12 521-PL307 YL - 0.75
87A
87A
87
85
87
85
PL-C68 K17 K18 MINI OR
T972-PL401 GN- 0.75 117-PL258 YL - 1.00 117-PL258 YL - 1.00 320-PL412 OR- 0.75 320-PL411 OR- 0.75 610-PL385 OR- 1.00 823-PL131 GN- 0.75 614-PL320 PU - 0.75 STAB LEVER SW (CP) / STAB PROXIMITY SW (SS) (SWG INPUT 05) 67 T907-PL178 GN- 0.75 125-PL378 RD- 0.75 125-PL378 RD- 0.75 SOLID STATE 13
(10) LH OPERATOR HANDLE 1 T993-PL46 BR - 0.75 119-PL386 PK - 2.00 119-PL386 PK - 2.00 610-PL393 OR- 2.00 973-PL193 BR - 0.75 614-PL409 PU - 0.75 QUICK COUPLER SW - ENGAGE PINS (SWG INPUT 6) 68 585-PL199 YL - 0.75 126-PL197 RD- 2.00 126-PL197 RD- 2.00 3915143 X10 14
87A
86
30
86
30
MAXI FRONT
87
85
387-6565 HK-C2 HK-C1 PL-C50
MOM
T993-PL48 BR - 0.75 122-PL416 BU - 3.00 122-PL416 BU - 3.00 450-PL67 YL - 0.75 611-PL49 PU - 0.75 977-PL192 YL - 0.75 (28) LOADER LOCK SWITCH KEY SW RUN SIGNAL (+ BTRY) 69 308-PL181 YL - 0.75 126-PL203 RD- 2.00 126-PL203 RD- 2.00 X977-PL243 YL - 1.00 1 HORN 15 321-PL103 BR - 0.75
3463501 3463511 3463501 X800-PL373 OR - 0.75 123-PL79 WH- 1.00 123-PL79 WH- 1.00 105-PL150 RD- 0.75 450-PL33 YL - 0.75 450-PL238 YL - 0.75 611-PL51 PU - 1.00 C720-PL271 BU - 0.75 708-PL208 YL - 0.75 708-PL208 YL - 0.75 387-6518 70 126-PL204 RD- 2.00 126-PL204 RD- 2.00 124-PL306 GN- 0.75 2 AIR CON COMP F16 10A JHKJH c1
c10
16
MICRO
A A A122-PL361 YL - 0.75 124-PL306 GN- 0.75 124-PL306 GN- 0.75 115-PL173 RD- 1.00 611-PL85 PU - 2.00 E701-PL270 PK - 0.75 718-PL126 BU - 0.75 718-PL126 BU - 0.75 71 131-PL147 BR - 1.00 131-PL147 BR- 1.00 158-PL255 BR - 1.00 3 FR FLOOD F15 15A 17 320-PL166 OR- 0.75
B B T993-PL46 BR - 0.75 115-PL351 RD- 1.00 453-PL274 PK - 0.75 453-PL274 PK - 0.75 611-PL319 PU - 1.00 F748-PL206 WH- 0.75 719-PL128 GY- 0.75 719-PL128 GY- 0.75 NOTE P 72 131-PL421 BR - 1.00 131-PL421 BR- 1.00 133-PL369 OR- 0.75 4 MONITOR F19 10A 18 519-PL15 PK - 0.75
87A
87A
87
85
87
85
C C M948-PL105 BR - 0.75 131-PL395 BR - 1.00 131-PL7 BR - 1.00 123-PL79 WH- 1.00 614-PL28 PU - 0.75 J878-PL328 YL - 0.75 823-PL131 GN- 0.75 823-PL131 GN- 0.75 XMSN SPEED CLUTCH 2 (ON/OFF SOURCING DRVR 4) 73 903-PL231 GY- 0.75 133-PL369 OR- 0.75 133-PL369 OR- 0.75 307-PL265 OR- 0.75 5 D5 19 518-PL44 OR- 1.00
D D M947-PL124 OR- 0.75 131-PL147 BR - 1.00 131-PL7 BR - 1.00 506-PL116 PU - 0.75 614-PL218 PU - 0.75 973-PL193 BR - 0.75 973-PL193 BR - 0.75 XMSN AUTO / MANUAL SW - AUTO (SWG INPUT 1) 74 977-PL192 YL - 0.75 202-PL26 BK - 3.00 136-PL357 GN- 1.00 136-PL357 GN- 1.00 157-PL256 YL - 1.00 6 FR FLOOD ATCH F14 15A
K9
REAR HORN 20 A305-PL53 YL - 0.75
SW RTN E 200-HK2 BK - 0.75 E 200-PL32 BK - 0.75 136-PL357 GN- 1.00 506-PL160 PU - 0.75 617-PL338 BR - 0.75 977-PL192 YL - 0.75 977-PL192 YL - 0.75 XMSN AUTO / MANUAL SW - MANUAL (SWG INPUT 2) 75 973-PL193 BR - 0.75 202-PL370 BK - 2.00 143-PL138 BR - 1.00 143-PL138 BR- 1.00 144-PL389 GN- 1.00 7 BEACON F18 15A
MICRO
21 537-PL318 GN- 0.75
HORN SW - NO F A305-HK1 YL - 0.75 F A305-PL402 YL - 0.75 133-PL47 OR- 0.75 133-PL84 OR- 0.75 143-PL404 BR - 1.00 506-PL168 PU - 0.75 618-PL335 YL - 0.75 C720-PL271 BU - 0.75 C720-PL271 BU - 0.75 DIFF LOCK SW (SWG INPUT 3) 76 R908-PL20 YL - 0.75 144-PL389 GN- 1.00 144-PL389 GN- 1.00 131-PL147 BR - 1.00 8 DIFF LOCK F13 15A + BTRY 49
G G 133-PL369 OR- 0.75 161-PL30 RD- 1.00 619-PL293 GN- 1.00 E701-PL270 PK - 0.75 E701-PL270 PK - 0.75 QUICK COUPLER SW PARITY (SWB INPUT 1) 77 779-PL194 WH- 0.75 202-PL345 BK - 1.00 157-PL256 YL - 1.00 157-PL256 YL- 1.00 9 SPARE SB F41 15A GND 31 PL-C22
H H 200-PL3 BK - 0.75 507-PL114 WH- 0.75 507-PL114 WH- 0.75 619-PL310 GN- 1.00 F748-PL206 WH- 0.75 F748-PL206 WH- 0.75 BRAKE PEDAL SW - LEFT (SWB INPUT 2) 78 C789-PL247 YL - 0.75 158-PL255 BR - 1.00 158-PL255 BR- 1.00 200-PL333 BK - 0.75 10 LAMP OUT 49A X15 3500481
J J 136-PL357 GN- 1.00 200-PL23 BK - 0.75 619-PL341 GN- 2.00 BRAKE PEDAL SW - RIGHT (SWB INPUT 3) 79 720-PL254 PU - 0.75 159-PL317 BU - 1.00 159-PL317 BU- 1.00 131-PL421 BR - 1.00 11 1
(35) RIDE CONTROL LL SWITCH
MOM
MOM
K K H802-PL159 GY- 0.75 200-PL240 BK - 2.00 537-PL323 GN- 0.75 537-PL283 GN- 0.75 627-PL374 YL - 0.75 J878-PL162 YL - 0.75 80 (7) CONTROL GROUND 161-PL30 RD- 1.00 161-PL30 RD- 1.00 159-PL317 BU - 1.00 12 TURN SIG F12 15A 2
FLASHER
L L T970-PL400 GY- 0.75 202-PL144 BK - 0.75 537-PL318 GN- 0.75 708-PL208 YL - 0.75 J878-PL279 YL - 0.75 387-6569 MACHINE GND - BTRY (-) 81 202-PL187 BK - 2.00 180-PL261 GN- 2.00 180-PL261 GN- 2.00 3
PL-C66 K23
M M T972-PL401 GN- 0.75 143-PL138 BR - 1.00 202-PL345 BK - 1.00 718-PL126 BU - 0.75 J878-PL328 YL - 0.75 J878-PL286 YL - 0.75 MACHINE GND - BTRY (-) 82 202-PL191 BK - 2.00 4 N939-PL359 GN - 0.75
143-PL21 BR - 1.00 143-PL404 BR - 1.00 307-PL163 OR- 0.75 552-PL5 WH- 0.75 719-PL128 GY- 0.75 J878-PL332 YL - 0.75 NOTE P MACHINE GND - BTRY (-) 83 202-PL216 BK - 2.00 NOTE A 200-PL104 BK- 0.75 200-PL380 BK- 0.75 3500478 X11 NEUTRALISER 5 202-PL414 BK - 1.00
LOW SIDE
CONN 5 308-PL59 YL - 0.75 552-PL8 WH- 0.75 720-PL123 PU - 0.75 J878-PL334 YL - 0.75 UN-SWITCHED BTRY (+) 84 126-PL197 RD- 2.00 200-PL143 BK- 0.75 200-PL333 BK- 0.75 617-PL340 BR- 0.75 1 LH TAIL F38 10A CONTROL
K22 6
NOT K19
REAR AUX (HORN) 144-PL389 GN- 1.00 144-PL389 GN- 1.00 308-PL417 YL - 0.75 552-PL54 WH- 0.75 720-PL234 PU - 0.75 E701-PL270 PK - 0.75 UN-SWITCHED BTRY (+) 85 126-PL204 RD- 2.00 200-PL349 BK- 0.75 618-PL337 YL- 0.75 2 RH TAIL F39 10A
MICRO FITTED 7
157-PL256 YL - 1.00 157-PL256 YL - 1.00 320-PL412 OR- 0.75 766-PL133 GN- 0.75 F748-PL206 WH- 0.75 UN-SWITCHED BTRY (+) 86 126-PL203 RD- 2.00 200-PL350 BK- 0.75 614-PL248 PU- 0.75 3 BACKLIGHT F37 10A NEUTRAL 8
LOCK
158-PL255 BR - 1.00 158-PL255 BR - 1.00 450-PL33 YL - 0.75 585-PL199 YL - 0.75 585-PL199 YL - 0.75 779-PL194 WH- 0.75 F739-PL339 GN- 0.75 200-PL405 BK- 2.00 4 DIFF LOCK NOT NOT ALARM
9
159-PL317 BU - 1.00 159-PL317 BU - 1.00 453-PL274 PK - 0.75 586-PL200 BR - 0.75 823-PL131 GN- 0.75 PL-C32 200-PL272 BK - 2.00 200-PL305 BK- 3.00 200-PL380 BK- 0.75 5 FITTED FITTED 10
3748333 K12
507-PL114 WH- 0.75 852-PL205 GN- 0.75 C743-PL344 PK - 0.75 614-PL320 PU- 0.75 J2 200-PL322 BK - 2.00 200-PL330 BK- 1.00 6 MICRO 11
K21
HJ-C1 161-PL176 RD- 1.00 161-PL30 RD- 1.00 537-PL323 GN- 0.75 601-PL42 GY- 2.00 973-PL193 BR - 0.75 202-PL165 BK - 0.75 5V SUPPLY - LOADER AUX CTRL (THUMB ROLLER) 1 A119-PL37 YL - 0.75 200-PL381 BK - 3.00 7 12
3463511 161-PL179 RD- 1.00 585-PL199 YL - 0.75 976-PL98 OR- 0.75 8 1 3 4 6 10 2 200-PL396 BK - 3.00 202-PL370 BK- 2.00 123-PL354 WH- 1.00 8 CP ENG SNSR F20 15A 13 P832-PL282 WH- 0.75
86
30
1B 2B NOT LOWER
A122-HJ1 YL - 0.75 A 604-PL71 OR- 0.75 604-PL71 OR- 0.75 604-PL71 OR- 0.75 977-PL192 YL - 0.75 HOE AUX VALVE 1 PORT B (PWM DRVR 6) 3 T969-PL221 YL - 0.75 200-PL305 BK - 3.00 123-PL262 WH- 1.00 9 FITTED ENABLE MICRO 14 P832-PL403 WH- 0.75
T993-HJ2 BR - 0.75 B 200-PL23 BK - 0.75 604-PL72 OR- 0.75 604-PL72 OR- 0.75 604-PL72 OR- 0.75 (34) RIDE CONTROL SWITCH HOE AUX VALVE 2 PORT A (PWM DRVR 7) 4 T972-PL219 GN- 0.75 200-PL396 BK- 3.00 10 D4 15 G703-PL390 GN - 0.75
PARK BRAKE
LEFT TURN
M948-HJ3 BR - 0.75 C 200-PL240 BK - 2.00 604-PL146 OR- 0.75 604-PL146 OR- 0.75 604-PL146 OR- 0.75 A119-PL364 YL - 0.75 LH IND LAMP HOE AUX VALVE 2 PORT B (PWM DRVR 8) 5 T970-PL217 GY- 0.75 123-PL79 WH- 1.00 11 MICRO 16 F738-PL233 WH- 0.75
387-6594
M947-HJ11 OR- 0.75 D 200-PL322 BK - 2.00 604-PL184 OR- 0.75 604-PL184 OR- 0.75 604-PL184 OR- 0.75 A119-PL375 YL - 0.75 214-4717 HOE AUX VALVE 1 PORT A (PWM DRVR 9) 6 T971-PL222 OR- 0.75 (9) LOWER CAB GROUND 307-PL163 OR- 0.75 307-PL163 OR- 0.75 123-PL397 WH- 1.00 12 17 131-PL421 BR - 1.00
87A
PL-C12
G G
87
85
200-HJ4 BK - 0.75 E CONN 5 200-PL32 BK - 0.75 200-PL3 BK - 0.75 605-PL89 YL - 0.75 605-PL89 YL - 0.75 605-PL89 YL - 0.75 C720-PL271 BU - 0.75 PL-C19 NOTE P 7 2 5 9 2285856 7 200-PL303 BK - 2.00 307-PL265 OR- 0.75 102-PL17 RD- 2.00 13 ROAD/POS LT F33 20A MICRO 18 322-PL294 GY- 0.75
A305-HJ5 YL - 0.75 F CONNECTS TO PL-C50 200-PL136 BK - 1.00 605-PL90 YL - 0.75 605-PL90 YL - 0.75 605-PL90 YL - 0.75 C704-PL251 GY- 0.75 202-PL43 BK - 0.75 1A 2A 2055471 8 102-PL1 RD- 2.00 14 19 123-PL397 WH- 1.00
G VOL 1 LOC H-16 200-PL321 BK - 1.00 605-PL91 YL - 0.75 605-PL91 YL - 0.75 605-PL91 YL - 0.75 C707-PL252 PK - 0.75 202-PL164 BK - 0.75 202-PL301 BK - 0.75 5V SUPPLY - 8TH FUNCTION CTRL (THUMB ROLLER) 9 A122-PL226 YL - 0.75 NOTE A 307-PL281 OR- 0.75 123-PL420 WH- 1.00 15 20 367-PL379 BU - 0.75
H 606-PL50 GY- 0.75 606-PL50 GY- 0.75 606-PL50 GY- 0.75 C743-PL344 PK - 0.75 202-PL165 BK - 0.75 605-PL91 YL - 0.75 308-PL311 YL - 0.75 PWM RTN: DRVR 10, 11, 12 10 J879-PL237 GN- 0.75 21
J 200-PL143 BK - 0.75 200-PL143 BK - 0.75 606-PL86 GY- 0.75 606-PL86 GY- 0.75 606-PL86 GY- 0.75 C789-PL106 YL - 0.75 308-PL25 YL - 0.75 308-PL25 YL - 0.75 J878-PL334 YL - 0.75 11 308-PL108 YL- 0.75 308-PL108 YL - 0.75
H802-HJ8 GY- 0.75 K 200-PL303 BK - 2.00 200-PL303 BK - 2.00 606-PL87 GY- 0.75 606-PL87 GY- 0.75 606-PL87 GY- 0.75 C789-PL152 YL - 0.75 XMSN REV CLUTCH RTN (PWM 2 RTN) 12 F761-PL45 BR - 0.75 331-PL41 OR- 0.75 331-PL41 OR- 0.75
T970-HJ6 GY- 0.75 L 200-PL381 BK - 3.00 200-PL381 BK - 3.00 607-PL325 PK - 1.00 607-PL325 PK - 1.00 607-PL325 PK - 1.00 E701-PL270 PK - 0.75 605-PL91 YL - 0.75 202-PL164 BK - 0.75 MAIN HYDRAULIC PUMP SOL (PWM DRVR 10) 13 H705-PL149 BR - 0.75 515-PL40 GY- 0.75 515-PL40 GY- 0.75 RIDE CONT F21 10A
T972-HJ7 GN- 0.75 M 200-PL396 BK - 3.00 200-PL396 BK - 3.00 608-PL268 GN- 1.00 608-PL268 GN- 1.00 608-PL268 GN- 1.00 F711-PL31 YL - 0.75 606-PL87 GY- 0.75 202-PL43 BK - 0.75 610-PL393 OR- 2.00 14 614-PL248 PU - 0.75 614-PL248 PU - 0.75 K7
202-PL92 BK - 0.75 202-PL92 BK - 0.75 614-PL155 PU - 0.75 F711-PL99 YL - 0.75 611-PL49 PU - 0.75 601-PL42 GY- 2.00 15 617-PL340 BR - 0.75 617-PL340 BR - 0.75
1B 2B K25 K26
202-PL144 BK - 0.75 202-PL144 BK - 0.75 614-PL174 PU - 0.75 610-PL115 OR- 2.00 F712-PL100 GN- 0.75 C743-PL344 PK - 0.75 16 618-PL337 YL- 0.75 618-PL337 YL - 0.75 FUEL PUMP F17 10A
86
30
8 1 3 4 6 10 K24
202-PL299 BK - 1.00 202-PL299 BK - 1.00 614-PL308 PU - 0.75 610-PL385 OR- 1.00 F712-PL387 GN- 0.75 5V SUPPLY - 7TH FUNCTION CTRL (THUMB ROLLER) 17 997-PL304 OR- 0.75
86
30
AWD
RH TURN
HI BEAM
202-PL345 BK - 1.00 617-PL338 BR - 0.75 610-PL393 OR- 2.00 F748-PL206 WH- 0.75 RH IND AS 18 E747-PL63 BK- 0.75 E747-PL63 BK - 0.75 NOT
PARK
618-PL335 YL - 0.75 G703-PL390 GN- 0.75 214-4723 (36) ROADING SWITCH HYD OIL TEMP SNSR RTN (ANLG RTN) 19 L740-PL188 BR - 0.75 G962-PL177 OR- 0.75 BRAKE D6
MICRO FITTED NOT
(11) LH OPERATOR HANDLE 2 HJ-C2 307-PL163 OR- 0.75 307-PL163 OR- 0.75 627-PL374 YL - 0.75 611-PL51 PU - 1.00 G760-PL135 WH- 0.75 PL-C17 387-6558 20
87A
MICRO FITTED
87
85
387-6564 3463501 308-PL59 YL - 0.75 308-PL59 YL - 0.75 766-PL82 GN- 0.75 611-PL319 PU - 1.00 G761-PL140 YL - 0.75 2055471 21 M947-PL196 OR- 0.75
87A
1A 2A PL-C21
87
85
5V PWR A A122-HJ1 YL - 0.75 308-PL417 YL - 0.75 308-PL417 YL - 0.75 611-PL49 PU - 0.75 G762-PL141 BR - 0.75 7 2 5 9 2285856 22 FUEL PUMP
5V RETURN B T993-HJ2 BR - 0.75 309-PL10 GY- 0.75 309-PL10 GY- 0.75 C743-PL55 PK - 0.75 611-PL85 PU - 2.00 G763-PL113 PU - 0.75 611-PL49 PU - 0.75 23 M948-PL209 BR - 0.75 MICRO RIDE CONT K20
LH ROLLER SIGNAL 1 C M948-HJ3 BR - 0.75 310-PL295 PU - 0.75 310-PL295 PU - 0.75 F711-PL77 YL - 0.75 G768-PL121 GN- 0.75 606-PL87 GY- 0.75 202-PL186 BK - 0.75 24
LH ROLLER SIGNAL 2 D M947-HJ11 OR- 0.75 320-PL412 OR- 0.75 320-PL412 OR- 0.75 F711-PL239 YL - 0.75 614-PL155 PU - 0.75 614-PL28 PU - 0.75 G956-PL66 BU - 0.75 102-PL1 RD- 2.00 AWD SOL (PWM DRVR 11) 25 552-PL5 WH- 0.75 M963-PL170 BU - 0.75 MICRO LOWER
86
30
JHKJH c3
c12
SW RTN E 200-HJ4 BK - 0.75 321-PL103 BR - 0.75 321-PL103 BR - 0.75 F712-PL78 GN- 0.75 614-PL174 PU - 0.75 614-PL248 PU - 0.75 H735-PL180 GY- 0.75 RTN FOR ALL SWG SWITCHES 26 J878-PL210 YL - 0.75 COMMAND
MINI FUSES
HORN SW-NO F A305-HJ5 YL - 0.75 367-PL379 BU - 0.75 367-PL379 BU - 0.75 F712-PL242 GN- 0.75 614-PL308 PU - 0.75 614-PL218 PU - 0.75 H904-PL110 GY- 0.75 XMSN OUTPUT SPEED SENSOR 1 (-) 27 E901-PL183 GN- 0.75 P832-PL403 WH- 0.75 P832-PL403 WH- 0.75 10A 113-8490 MICRO
G 404-PL245 YL - 0.75 404-PL245 YL - 0.75 H801-PL117 PU - 0.75 J764-PL6 BR - 0.75 PL-C58 977-PL192 YL - 0.75 28 X977-PL243 YL - 1.00 X977-PL243 YL - 1.00
2698225 15A 113-8491 K1
H 405-PL122 GY- 0.75 405-PL122 GY- 0.75 H802-PL159 GY- 0.75 617-PL338 BR - 0.75 617-PL338 BR - 0.75 J764-PL127 BR - 0.75 973-PL193 BR - 0.75 29 X977-PL422 YL - 1.00 X977-PL422 YL - 1.00
87A
87
85
20A 113-8492
J 420-PL316 OR- 0.75 420-PL316 OR- 0.75 H802-PL220 GY- 0.75 618-PL335 YL - 0.75 618-PL335 YL - 0.75 J878-PL2 YL - 0.75 131-PL7 BR - 1.00 1 614-PL62 PU - 0.75 30 START
86
30
STANDARD FUSES
K 439-PL288 YL - 0.75 439-PL288 YL - 0.75 J764-PL263 BR - 0.75 J878-PL14 YL - 0.75 202-PL18 BK - 0.75 2 31
10A 9W-1442
L 441-PL38 OR- 0.75 441-PL38 OR- 0.75 J878-PL69 YL - 0.75 619-PL293 GN- 1.00 J878-PL24 YL - 0.75 200-PL23 BK - 0.75 3 8 1 3 4 6 10 32
15A 9W-1441 RELAYS MAXI
M 447-PL156 PK - 0.75 447-PL156 PK - 0.75 J878-PL292 YL - 0.75 619-PL310 GN- 1.00 J878-PL328 YL - 0.75 852-PL205 GN- 0.75 4 XMSN FWD HIGH CLUTCH (PWM DRVR 12) 33 900-PL228 PU - 0.75 20A 9W-1446 20A MICRO 140-9378
450-PL33 YL - 0.75 450-PL33 YL - 0.75 R912-PL227 OR- 1.00 619-PL341 GN- 2.00 J878-PL382 YL - 0.75 P993-PL151 OR- 0.75 5 CONN 12 (25) AUTO/MAN SWITCH 34
87A
87
85
25A 1Q-1905 30 MINI 3E-9362
452-PL139 PU - 0.75 452-PL139 PU - 0.75 T993-PL46 BR - 0.75 N939-PL359 GN- 0.75 J878-PL24 YL - 0.75 6 CONNECTS TO KP-C2 387-6582 XMSN OUTPUT SPEED SENSOR 1 (+) 35 E900-PL182 WH- 0.75
HJ-C3 MAXI FUSES 70A MAXI 265-8025
453-PL274 PK - 0.75 453-PL274 PK - 0.75 T993-PL48 BR - 0.75 627-PL374 YL - 0.75 627-PL374 YL - 0.75 P832-PL282 WH- 0.75 614-PL28 PU - 0.75 7 VOL 2 LOC A-13 PL-C63 36
30A 197-7727 K15 SOLID STATE 278-0461
2458026 507-PL114 WH- 0.75 507-PL114 WH- 0.75 X800-PL373 OR- 0.75 708-PL208 YL - 0.75 P993-PL151 OR- 0.75 585-PL199 YL - 0.75 8 2285856 FNR CONTROL - FWD (FREQ / PWM INPUT 11) 37 C704-PL251 GY- 0.75 308-PL181 YL - 0.75
(23) HOE AUX VALVE 2 SOLENOID 1 7 2 5 9 40A 232-6313 NON-LED FLASHER 374-9636
362-3212 BK-18 1 T970-HJ6 GY- 0.75 T970-HJ6 GY- 0.75 515-PL40 GY- 0.75 515-PL40 GY- 0.75 R908-PL20 YL - 0.75 586-PL200 BR - 0.75 9 FNR CONTROL - REV (FREQ / PWM INPUT 12) 38 C707-PL252 PK - 0.75 450-PL238 YL - 0.75 50A 418-0363 LED FLASHER 387-6632
X3 STUD
PORT B BK-18 2 H802-HJ9 GY- 0.75 518-PL44 OR- 1.00 518-PL44 OR- 1.00 718-PL126 BU - 0.75 R912-PL227 OR- 1.00 779-PL194 WH- 0.75 10 202-PL289 BK - 0.75 39 552-PL5 WH- 0.75 60A 232-6314 K16 RELAY LINK 441-4289
314-PL260 PU- 3.00
519-PL15 PK - 0.75 519-PL15 PK - 0.75 T993-PL407 BR - 0.75 11 308-PL285 YL - 0.75 40 586-PL200 BR - 0.75
537-PL323 GN- 0.75 537-PL323 GN- 0.75 719-PL128 GY- 0.75 X800-PL185 OR- 0.75 12 J878-PL286 YL - 0.75 41 708-PL208 YL - 0.75
568-PL236 GN- 0.75 568-PL236 GN- 0.75 Y973-PL57 WH- 0.75 42 718-PL126 BU - 0.75
F (24) HOE AUX VALVE 2 SOLENOID 2
HJ-C4
2458026
585-PL199 YL - 0.75
720-PL123 PU - 0.75
Y974-PL39 BU - 0.75
FRONT DASH PANEL
FNR CONTROL - NEUT (FREQ / PWM INPUT 13)
FNR CONTROL - GEAR 1 (FREQ / PWM INPUT 14)
43
44
G763-PL113 PU - 0.75
G768-PL121 GN - 0.75
719-PL128 GY- 0.75
766-PL154 GN- 0.75
F
362-3212 BK-18 1 T972-HJ7 GN- 0.75 T972-HJ7 GN- 0.75 720-PL234 PU - 0.75 45 779-PL194 WH- 0.75
BK-18 2 H802-HJ10 GY- 0.75 H802-HJ8 GY- 0.75 604-PL71 OR- 0.75 720-PL254 PU - 0.75 FNR CONTROL - GEAR 2 (FREQ / PWM INPUT 15) 46 G760-PL135 WH - 0.75 823-PL131 GN- 0.75 PL-C38
PORT A
604-PL72 OR- 0.75 47 852-PL205 GN- 0.75 3313578
604-PL327 OR- 0.75 604-PL146 OR- 0.75 766-PL133 GN- 0.75 (4) FNR MANUAL CONTROL (3) FNR AUTOSHIFT CONTROL 48 973-PL193 BR - 0.75 125-PL378 RD- 0.75 1
604-PL367 OR- 0.75 604-PL184 OR- 0.75 766-PL82 GN- 0.75 766-PL154 GN- 0.75 PL-C10 310-9355 310-9354 49 976-PL98 OR- 0.75 202-PL93 BK - 0.75 2 CONN 21
REAR AUX (8TH FUNCTION) - ATCH 766-PL189 GN- 0.75 2698225 FNR CONTROL - GEAR 3 (FREQ / PWM INPUT 16) 50 G761-PL140 YL - 0.75 977-PL192 YL - 0.75 308-PL94 YL - 0.75 3 CONNECTS TO PROD LINK 631/641
NOTE Y 605-PL172 YL - 0.75 605-PL89 YL - 0.75 J878-PL2 YL - 0.75 1 1 FNR CONTROL - GEAR 4 (FREQ / PWM INPUT 17) 51 G762-PL141 BR - 0.75 4
VOL 2 LOC E-5/D-5
605-PL329 YL - 0.75 605-PL90 YL - 0.75 779-PL194 WH- 0.75 C704-PL251 GY- 0.75 2 2 LOADER CONT FLOW SW - N/C (SWG INPUT 20) 52 P993-PL151 OR- 0.75 A119-PL37 YL - 0.75 H3 5
OR
605-PL365 YL - 0.75 605-PL91 YL - 0.75 105-PL60 RD- 1.00 C707-PL252 PK - 0.75 3 F 3 F HOE AUX CONT FLOW SW - N/O (SWG INPUT 21) 53 M937-PL300 GN- 0.75 C704-PL251 GY- 0.75 102-PL1 RD- 2.00 6
N N CONNECTS TO PH-C1
106-PL169 RD- 0.75 823-PL131 GN- 0.75 G763-PL113 PU - 0.75 4 4 54 C707-PL252 PK - 0.75 102-PL17 RD- 2.00 7
N N VOL 3 LOC I-8
606-PL171 GY- 0.75 606-PL50 GY- 0.75 200-PL322 BK - 2.00 320-PL411 OR- 0.75 5 R 5 HORN R 55 C720-PL271 BU - 0.75 105-PL150 RD- 0.75 8
606-PL331 GY- 0.75 606-PL86 GY- 0.75 116-PL257 BR - 1.00 852-PL205 GN- 0.75 200-PL3 BK - 0.75 6 CONNECTS TO PL-C10 6 56 C743-PL207 PK - 0.75 111-PL241 RD- 1.00 9 OR
(20) POWER PORT 115-PL351 RD- 1.00 105-PL213 RD- 0.75 606-PL366 GY- 0.75 606-PL87 GY- 0.75 117-PL258 YL - 1.00 G768-PL121 GN- 0.75 7 VOL 1 LOC F-11 7 PARKING BRAKE SW (GND = BRAKE ON) (SWG INPUT 23) 57 C743-PL207 PK - 0.75 E701-PL270 PK - 0.75 115-PL190 RD- 1.00 10 CONNECTS TO PA-C1
178-7539 200-PL321 BK - 1.00 105-PL235 RD- 1.00 119-PL386 PK - 2.00 973-PL193 BR - 0.75 G760-PL135 WH- 0.75 8 HORN 8 58 F711-PL276 YL - 0.75 118-PL388 GY- 2.00 F711-PL406 YL - 0.75 11 VOL 2 LOC D-9
1
106-PL169 RD- 0.75 607-PL129 PK - 1.00 607-PL129 PK - 1.00 122-PL416 BU - 3.00 G761-PL140 YL - 0.75 9 9 2 RIDE CONTROL SW - AUTO (SWG INPUT 25) 59 E701-PL270 PK - 0.75 F712-PL277 GN- 0.75 123-PL79 WH- 1.00 F712-PL346 GN- 0.75 12
115-PL173 RD- 1.00 607-PL325 PK - 1.00 607-PL325 PK - 1.00 124-PL306 GN- 0.75 976-PL98 OR- 0.75 G762-PL141 BR - 0.75 10 10 3 60 F748-PL206 WH- 0.75 123-PL354 WH- 1.00
4
115-PL351 RD- 1.00 608-PL153 GN- 1.00 608-PL153 GN- 1.00 131-PL147 BR - 1.00 11 11
GEAR
61 G760-PL135 WH- 0.75 125-PL378 RD- 0.75
116-PL257 BR - 1.00 608-PL268 GN- 1.00 608-PL268 GN- 1.00 133-PL84 OR- 0.75 977-PL192 YL - 0.75 12 12 62 G956-PL66 BU - 0.75
PL-C27 117-PL258 YL - 1.00 614-PL155 PU - 0.75 614-PL155 PU - 0.75 133-PL369 OR- 0.75 XMSN NEUTRALISER / DOWNSHIFT SW (SWG INPUT 29) 63 766-PL154 GN- 0.75 H801-PL201 PU - 0.75 161-PL30 RD- 1.00 NOTE DESCRIPTION
1519278 119-PL386 PK - 2.00 614-PL174 PU - 0.75 614-PL174 PU - 0.75 136-PL357 GN- 1.00 AUTOSHIFT OPTION 64 H802-PL111 GY- 0.75 200-PL12 BK - 0.75 PL-C16
(30) PARKING BRAKE SWITCH 3463503 NOTE A: ASSEMBLE TERMINALS TO DESIGNATED STUD
BK-18 1 C743-PL55 PK - 0.75 122-PL416 BU - 3.00 614-PL308 PU - 0.75 614-PL308 PU - 0.75 143-PL138 BR - 1.00 A119-PL37 YL - 0.75 8TH FUNCTION CTRL (THUMB ROLLER) (SIG 1) (+) 65 M948-PL209 BR - 0.75 H904-PL110 GY- 0.75 200-PL104 BK - 0.75
154-5416 BK-18 2 J878-PL69 YL - 0.75 123-PL79 WH - 1.00 144-PL389 GN- 1.00 A119-PL364 YL - 0.75 8TH FUNCTION CTRL (THUMB ROLLER) (SIG 2) (-) 66 M947-PL196 OR- 0.75 720-PL254 PU - 0.75 200-PL330 BK - 1.00 900-PL228 PU - 0.75 A SYMBOL DESCRIPTION NOTE B: WHEN FITTED, CONNECT X739-BR TO DOME LIGHT (SH 2 LOC F-4)
124-PL306 GN- 0.75 617-PL125 BR - 0.75 617-PL338 BR - 0.75 157-PL256 YL - 1.00 A119-PL375 YL - 0.75 (29) MULTI FUNCTION COLUMN SWITCH
7TH FUNCTION CTRL (THUMB ROLLER) (SIG 1) (+) 67 M962-PL269 YL - 0.75 C789-PL247 YL - 0.75 200-PL349 BK - 0.75 902-PL232 BR - 0.75 B
131-PL395 BR - 1.00 617-PL336 BR - 0.75 617-PL340 BR - 0.75 158-PL255 BR - 1.00 273-9190
7TH FUNCTION CTRL (THUMB ROLLER) (SIG 2) (-) 68 M963-PL170 BU - 0.75 G761-PL140 YL - 0.75 200-PL350 BK - 0.75 903-PL231 GY- 0.75 C
CIRCUIT CONNECTED NOTE D: NOT USED ON 428/434F2 MODELS
133-PL47 OR- 0.75 159-PL317 BU - 1.00 C704-PL251 GY- 0.75 HYD OIL TEMP SENSOR (ANLG INPUT 3) 69 442-PL195 GY- 0.75 G762-PL141 BR - 0.75 200-PL405 BK - 2.00 552-PL54 WH- 0.75 D
143-PL21 BR - 1.00 618-PL343 YL - 0.75 618-PL335 YL - 0.75 200-PL381 BK - 3.00 HOE AUX CONT FLOW SW - N/C (SWG INPUT 30) 70 M936-PL287 BR - 0.75 G763-PL113 PU - 0.75 202-PL65 BK - 0.75 324-PL19 BU - 1.00 E
CONN 20 CIRCUIT NOT CONNECTED NOTE E: CONTACTS CLOSED WHEN BRAKE PEDAL IS DEPRESSED
144-PL389 GN- 1.00 618-PL384 YL - 0.75 618-PL337 YL - 0.75 200-PL143 BK - 0.75 C707-PL252 PK - 0.75 AWD SW (PIN 3) (SWG INPUT 31) 71 823-PL131 GN- 0.75 G768-PL121 GN- 0.75 202-PL370 BK - 2.00 754-PL212 BU - 0.75 F
PL-C49 157-PL256 YL - 1.00 200-PL303 BK - 2.00 PL-C9 AWD SW (PIN 4) (SWG INPUT 32) 72 719-PL128 GY- 0.75 H735-PL180 GY- 0.75 202-PL414 BK - 1.00 752-PL211 YL - 0.75 G
CONNECTS TO XA-C7
2698224 VOL 2 LOC H-8 ELECTRICAL CONNECTION TO NOTE F: ON AUTO-MECH MACHINES, CONNECT WIRE AS. FROM PIN 2 TO 3 ON CONNECTOR RH-C6.
3463503 158-PL255 BR - 1.00 627-PL374 YL - 0.75 627-PL374 YL - 0.75 200-PL396 BK - 3.00 C720-PL271 BU - 0.75 73 J878-PL210 YL - 0.75 452-PL139 PU - 0.75 H
MACHINE STRUCTURE
56b OR
A 603-PL377 PK - 1.00 159-PL317 BU - 1.00 743-PL278 PU - 0.75 743-PL278 PU - 0.75 202-PL92 BK - 0.75 619-PL341 GN- 2.00 1 YL HEADLIGHT 74 J764-PL97 BR - 0.75 307-PL163 OR- 0.75 J
56 FLASH CONNECTS TO XK-C3 INTERNAL ELECTRICAL CONNECTION NOTE G: OPTION BASED ON MACHINE CONFIGURATION
B 620-PL280 WH- 1.00 161-PL176 RD- 1.00 766-PL82 GN- 0.75 766-PL82 GN- 0.75 202-PL299 BK - 1.00 610-PL115 OR- 2.00 2 WH/YL TURN SIGNALS 75 P993-PL151 OR- 0.75 308-PL94 YL - 0.75 200-PL12 BK - 0.75 K
15/1 TO SURFACE OF COMPONENT
C 608-PL268 GN- 1.00 161-PL179 RD- 1.00 997-PL304 OR- 0.75 997-PL304 OR- 0.75 202-PL345 BK - 1.00 C743-PL55 PK - 0.75 C743-PL344 PK - 0.75 102-PL17 RD- 2.00 3 BK/PU 76 R908-PL20 YL - 0.75 308-PL108 YL - 0.75 F761-PL45 BR - 0.75 L VOL 2 LOC I-8
L NOTE H: NOT USED ON PILOT MACHINES
D 607-PL325 PK - 1.00 200-PL136 BK - 1.00 309-PL10 GY- 0.75 C743-PL207 PK - 0.75 605-PL90 YL - 0.75 4 PU/GN 77 T993-PL102 BR - 0.75 320-PL166 OR- 0.75 J879-PL237 GN- 0.75 M
R CONNECTOR
E 614-PL174 PU - 0.75 200-PL321 BK - 1.00 A122-PL309 YL - 0.75 A122-PL226 YL - 0.75 310-PL295 PU - 0.75 606-PL86 GY- 0.75 5 PU/RD AWD SW (PIN 6) (SWG INPUT 33) 78 718-PL126 BU - 0.75 X800-PL408 OR- 0.75 450-PL67 YL - 0.75 H801-PL4 PU - 0.75 N
56a NOTE J: ATTACHMENT
E CONN 6
F
G
630-PL275 GY- 1.00
604-PL327 OR- 0.75
200-PL381 BK - 3.00
200-PL396 BK - 3.00
A122-PL361 YL - 0.75 321-PL103
367-PL379
BR - 0.75
BU - 0.75
C789-PL106 YL - 0.75
C789-PL152 YL - 0.75
611-PL85
537-PL283
PU - 2.00
GN- 0.75
6
7
WH
PU/WH
49a L R
LOW BEAM XMSN LOCKOUT SW - DISABLED (SWG INPUT 34)
XMSN LOCKOUT SW - ENABLED (SWG INPUT 35)
79
80
708-PL208 YL - 0.75
C720-PL271 BU - 0.75
Y973-PL57
Y974-PL39
WH- 0.75
BU - 0.75
537-PL318 GN- 0.75
552-PL54 WH- 0.75
P
R H# CIRCUIT GROUPING DESIGNATION
NOTE K: WHEN LOADER LOCKS ARE INSTALLED, REMOVE JUMPER AND CONNECT PL-C46 TO LN-C2
E
CONNECTS TO HL-C4 H 605-PL329 YL - 0.75 202-PL92 BK - 0.75 A305-PL137 YL - 0.75 404-PL245 YL - 0.75 C789-PL247 YL - 0.75 8 NOT USED 81 601-PL42 GY- 2.00 202-PL92 BK - 0.75 S
202-PL144 BK - 0.75 A305-PL402 YL - 0.75 A305-PL53 YL - 0.75 405-PL122 GY- 0.75 HIGH BEAM NOT USED 82 607-PL325 PK - 1.00
VOL 2 LOC C-1 J 606-PL331 GY- 0.75 ATCH WIRE, CABLE, COMPONENT
K 617-PL336 BR - 0.75 202-PL299 BK - 1.00 A305-PL413 YL - 0.75 420-PL316 OR- 0.75 E701-PL270 PK - 0.75 NOT USED 83 608-PL268 GN- 1.00
NOTE L: WHEN REAR QUICK COUPLER IS FITTED, CONNECT KV-C7 TO PL-C35 AND CONNECT KV-C6 TO AC-C7.
L 618-PL343 YL - 0.75 307-PL163 OR- 0.75 A305-PL363 YL - 0.75 439-PL288 YL - 0.75 NOT USED 84 614-PL248 PU - 0.75
PL-C37 WIPER SPLICE
M 161-PL176 RD- 1.00 308-PL59 YL - 0.75 441-PL38 OR- 0.75 G956-PL66 BU - 0.75 NOT USED 85 766-PL189 GN- 0.75
308-PL417 YL - 0.75 C216-PL250 BK - 0.75 C216-PL250 BK - 0.75 447-PL156 PK - 0.75 2458025 NOT USED 86 PL-C5
N 119-PL386 PK - 2.00 31b BLADE, SPADE, RING OR SCREW
309-PL10 GY- 0.75 C510-PL11 WH- 0.75 C510-PL11 WH- 0.75 452-PL139 PU - 0.75 500-PL394 BR - 1.00 1 BN/BU H4 F711-PL95 YL - 0.75 105-PL150 RD- 0.75 105-PL150 RD- 0.75 3463501
P 507-PL114 WH- 0.75 53b TERMINAL NOTE M: FOR MACHINES WITHOUT AIR CON REPLACE HEATER AC SW WITH VENT SW.
R 123-PL79 WH- 1.00 310-PL295 PU - 0.75 C568-PL418 WH- 3.00 C568-PL418 WH- 3.00 515-PL40 GY- 0.75 F711-PL239 YL - 0.75 502-PL34 OR- 2.00 2 BK/BU/WH F711-PL406 YL - 0.75 123-PL262 WH- 1.00 123-PL262 WH- 1.00 E900-PL182 WH- 0.75 A
53
S 115-PL173 RD- 1.00 404-PL245 YL - 0.75 C568-PL419 WH- 3.00 C568-PL419 WH- 3.00 518-PL44 OR- 1.00 F711-PL302 YL - 0.75 F711-PL99 YL - 0.75 501-PL392 GN- 1.00 3 BK/BU/YL F712-PL96 GN- 0.75 125-PL378 RD- 0.75 125-PL378 RD- 0.75 E901-PL183 GN- 0.75 B
J
405-PL122 GY- 0.75 C743-PL55 PK - 0.75 C743-PL55 PK - 0.75 519-PL15 PK - 0.75 590-PL142 GY- 2.00 4 BK/BU/BN WASHER 200-EW1 BRAID - 11 F712-PL346 GN- 0.75 180-PL261 GN- 2.00 180-PL261 GN- 2.00 H705-PL149 BR - 0.75 C
420-PL316 OR- 0.75 E543-PL214 WH- 0.75 E543-PL214 WH- 0.75 568-PL236 GN- 0.75 118-PL368 GY- 2.00 5 BK/BU
15
G703-PL390 GN- 0.75 200-PL12 BK - 0.75 200-PL12 BK - 0.75 975-PL229 WH- 0.75 D CONN 19 NOTE N: CONTACTS CLOSED AT PROPER REFRIGERANT CHARGE
53c CONNECTS TO XA-C8
439-PL288 YL - 0.75 E544-PL215 GN- 0.75 E544-PL215 GN- 0.75 585-PL199 YL - 0.75 F711-PL352 YL - 0.75 F711-PL406 YL - 0.75 506-PL160 PU - 0.75 H801-PL4 PU - 0.75 200-PL272 BK - 2.00 200-PL272 BK - 2.00 J832-PL326 YL - 0.75
441-PL38 OR- 0.75 E711-PL273 OR- 0.75 E711-PL273 OR- 0.75 607-PL129 PK - 1.00
6 BK/YL
(8) ECM CAB GROUND J764-PL362 BR - 0.75 202-PL65 BK - 0.75 202-PL65 BK - 0.75
E
F VOL 2 LOC G-8 ABBREV COLOR NOTE P: FOR MACHINES WITH RIDE CONTROL AND LOADER LOCKS REPLACE RIDE CONT SW WITH
OR CONNECTS TO XK-C8 RIDE CONT LL SW.
447-PL156 PK- 0.75 608-PL153 GN- 1.00 J878-PL296 YL - 0.75 202-PL92 BK - 0.75 202-PL92 BK - 0.75 751-PL230 GN- 0.75 G
450-PL33 YL - 0.75 E747-PL259 BK - 0.75 E747-PL63 BK - 0.75 617-PL340 BR - 0.75 F711-PL297 YL - 0.75 F711-PL95 YL - 0.75 NOTE A N939-PL359 GN- 0.75 H VOL 2 LOC I-8 RD RED FOR MACHINES WITH LOADER LOCKS ONLY REPLACE RIDE CONT SW WITH LOADER LOCK SW.
452-PL139 PU - 0.75 E747-PL249 BK - 0.75 618-PL337 YL - 0.75 P832-PL282 WH- 0.75 202-PL26 BK - 3.00 M739-PL35 YL - 0.75 J
WH WHITE NOTE R: ON MACHINES WITH PILOT HOE CONTROL CONNECT IMP LOCKOUT SWITCH TO CONNECTOR RH-C6.
453-PL274 PK - 0.75 743-PL278 PU - 0.75 X800-PL16 OR- 0.75 202-PL187 BK - 2.00 202-PL93 BK - 0.75 X800-PL16 OR- 0.75 K
507-PL114 WH - 0.75 E917-PL224 WH- 0.75 E917-PL224 WH- 0.75 997-PL304 OR- 0.75 F711-PL198 YL - 0.75 F711-PL31 YL - 0.75 H 202-PL191 BK - 2.00 202-PL101 BK - 0.75 J764-PL362 BR - 0.75 L
OR ORANGE NOTE S: THERMOSTAT FITTED TO MACHINES WITH AIR CON ONLY.
515-PL40 GY- 0.75 E918-PL223 GN- 0.75 E918-PL223 GN- 0.75 T
202-PL216 BK - 2.00 J984-PL36 PK - 0.75 M
PL-C6
(14) ANTITHEFT KEYPAD
518-PL44 OR- 1.00 F420-PL225 GN- 0.75 F420-PL225 GN- 0.75 A122-PL226 YL - 0.75 H5
2698224
L
MOTOR
202-PL299 BK - 1.00 YL YELLOW NOTE T: WHEN BOTH HOSE BURST CHECK VALVE AND OBJECT HANDLING ARE FITTED
PL-C3 519-PL15 PK - 0.75 F711-PL77 YL - 0.75 F711-PL77 YL - 0.75 A305-PL53 YL - 0.75 F711-PL77 YL - 0.75 105-PL60 RD- 1.00 202-PL414 BK - 1.00
387-6573 CONNECT HA-C1 TO RH-C18 AND CONNECT HA-C3 TO TA-C2.
3463500 537-PL323 GN- 0.75 F711-PL239 YL - 0.75 F711-PL239 YL - 0.75 C216-PL250 BK - 0.75 F711-PL276 YL - 0.75 1 106-PL169 RD- 0.75 PK PINK
12 V BTRY A 105-PL213 RD- 0.75 568-PL236 GN- 0.75 F712-PL78 GN- 0.75 F712-PL78 GN- 0.75 C510-PL11 WH- 0.75 506-PL168 PU - 0.75 2 PU 116-PL257 BR - 1.00 308-PL94 YL - 0.75 308-PL94 YL - 0.75
GND B 202-PL299 BK - 1.00 603-PL377 PK - 1.00 F712-PL242 GN- 0.75 F712-PL242 GN- 0.75 C568-PL418 WH- 3.00 F712-PL242 GN- 0.75 500-PL394 BR - 1.00 3 BR (17) FRONT WIPER MOTOR 117-PL258 YL - 1.00 309-PL10 GY- 0.75 309-PL10 GY- 0.75 PL-C30 BK BLACK NOTE U: FOR MACHINES WITH RIDE CONTROL REMOVE JUMPER AND CONNECT RK-C1 TO PL-C40
CAN + C F711-PL239 YL - 0.75 G423-PL244 PK - 0.75 G423-PL244 PK - 0.75 C568-PL419 WH- 3.00 F712-PL134 GN- 0.75 F712-PL100 GN- 0.75 118-PL383 GY- 2.00 4 GY 473-7727 119-PL386 PK - 2.00 314-PL260 PU - 3.00 314-PL260 PU - 3.00 4529773
CAN - D F712-PL242 GN- 0.75 604-PL327 OR- 0.75 G962-PL177 OR- 0.75 G962-PL177 OR- 0.75 E543-PL214 WH- 0.75 200-PL202 BK - 0.75 5 BK 122-PL416 BU - 3.00 322-PL294 GY- 0.75 322-PL294 GY- 0.75 384-PL68 BU - 3.00 A1 GY GRAY
KEY SW - IGN E 308-PL417 YL - 0.75 605-PL172 YL - 0.75 H466-PL56 BU - 0.75 H466-PL56 BU - 0.75 E544-PL215 GN- 0.75 501-PL392 GN- 1.00 6 GN 123-PL397 WH- 1.00 324-PL19 BU - 1.00 324-PL19 BU - 1.00 384-PL13 BU - 3.00 A2
INPUT (SWG) OPTION F 605-PL329 YL - 0.75 H771-PL145 BR - 1.00 E711-PL273 OR- 0.75 F712-PL358 GN- 0.75 F712-PL346 GN- 0.75 590-PL142 GY- 2.00 7 GY 384-PL13 BU - 3.00 384-PL13 BU - 3.00 A3 PU PURPLE NOTE V: FOR MACHINES WITH REVERSING LIGHTS (BRAZIL ONLY) REPLACE RELAY LINK AT K16 WITH A MICRO RELAY.
OUTPUT 1 (SWG) G 743-PL278 PU - 0.75 606-PL171 GY- 0.75 E747-PL63 BK - 0.75 502-PL34 OR- 2.00 8 OR 123-PL420 WH- 1.00 384-PL68 BU - 3.00 384-PL68 BU - 3.00 521-PL307 YL - 0.75 B1
OUTPUT 2 (SWB) H K906-PL75 GN - 0.75 606-PL331 GY- 0.75 H801-PL117 PU - 0.75 H801-PL117 PU - 0.75 E747-PL249 BK - 0.75 404-PL245 YL - 0.75 405-PL315 GY- 0.75 B2 BR BROWN NOTE W: FOR POWER SIDESHIFT OPTION, REPLACE SIDE SHIFT LOCK SW WITH POWER SS SW
OUTPUT 3 (SWG) J 766-PL82 GN - 0.75 607-PL129 PK - 1.00 H802-PL159 GY- 0.75 H802-PL159 GY- 0.75 E917-PL224 WH- 0.75 F712-PL360 GN- 0.75 F712-PL96 GN- 0.75 124-PL306 GN- 0.75 B3
STARTER OUTPUT (SWB) K 607-PL325 PK - 1.00 H802-PL220 GY- 0.75 H802-PL220 GY- 0.75 E918-PL223 GN- 0.75 131-PL147 BR - 1.00 B4
GN GREEN NOTE X: LED LAMPS ARE STANDARD FITMENT ON SS MODELS WITH A CAB
608-PL153 GN- 1.00 J764-PL263 BR - 0.75 J764-PL263 BR - 0.75 F420-PL225 GN- 0.75 308-PL181 YL - 0.75 131-PL421 BR - 1.00 405-PL122 GY- 0.75 405-PL315 GY- 0.75 B5
BU BLUE
PL-C2 NOTE Y: 8TH FUNCTION (HOE AUX) IS A DEALER FIT OPTION ONLY.
608-PL268 GN- 1.00 J878-PL69 YL - 0.75 J878-PL69 YL - 0.75 G423-PL244 PK - 0.75 F712-PL298 GN- 0.75 F712-PL387 GN- 0.75 450-PL238 YL - 0.75 405-PL253 GY- 0.75 441-PL38 OR- 0.75 B6
614-PL155 PU - 0.75 J878-PL292 YL - 0.75 J878-PL292 YL - 0.75 G962-PL177 OR- 0.75 552-PL5 WH- 0.75 1237615 133-PL84 OR- 0.75
D 614-PL174 PU - 0.75
614-PL308 PU - 0.75
K906-PL75
M719-PL27
GN- 0.75
GN- 1.00
K906-PL75 GN- 0.75 K906-PL75 GN- 0.75
M936-PL287 BR - 0.75 F712-PL78 GN- 0.75
586-PL200 BR - 0.75
708-PL208 YL - 0.75
510-PL58 YL - 0.75
200-PL175 BK - 0.75
1
MOTOR
(16) FRONT WASHER MOTOR
133-PL369 OR- 0.75
136-PL357 GN- 1.00
420-PL264
420-PL316
OR- 0.75
OR- 0.75
420-PL324 OR- 0.75
B7
B8
B9
NOTE Z: CONNECTION SUPPLIED WITH ENGINE
D
2 375-5475
617-PL336 BR - 0.75 M937-PL300 GN- 0.75 F712-PL277 GN- 0.75 718-PL126 BU - 0.75 143-PL138 BR - 1.00 B10
618-PL343 YL - 0.75 M721-PL64 WH- 1.00 M947-PL196 OR- 0.75 719-PL128 GY- 0.75 144-PL389 GN- 1.00 439-PL266 YL - 0.75 439-PL70 YL - 0.75 E455-PL246 BR - 0.75 B11
620-PL280 WH - 1.00 M948-PL209 BR - 0.75 F748-PL206 WH- 0.75 720-PL254 PU - 0.75 PL-C4 157-PL256 YL - 1.00 439-PL288 YL - 0.75 B12
M936-PL287 BR - 0.75 M936-PL287 BR - 0.75 M962-PL269 YL - 0.75 766-PL154 GN- 0.75 2458026 158-PL255 BR - 1.00 322-PL294 GY- 0.75 C1
(32) RETURN TO DIG SWITCH (PL)
630-PL275 GY- 1.00 M937-PL300 GN- 0.75 M937-PL300 GN- 0.75 M963-PL170 BU - 0.75 G703-PL390 GN- 0.75 779-PL194 WH- 0.75 510-PL58 YL - 0.75 1 (5) WASHER DIODE PW-C2 PW-C1 284-0078 159-PL317 BU - 1.00 441-PL38 OR- 0.75 441-PL38 OR- 0.75 202-PL65 BK - 0.75 C2
H466-PL56 BU - 0.75 823-PL131 GN- 0.75 506-PL116 PU - 0.75 2 189-3158 3E3370 2228935 180-PL261 GN- 2.00 442-PL195 GY- 0.75 442-PL195 GY- 0.75 447-PL156 PK - 0.75 C3
PL-C35
743-PL278 PU - 0.75 M947-PL119 OR- 0.75 M947-PL196 OR- 0.75 T907-PL178 GN- 0.75 G760-PL135 WH- 0.75 852-PL205 GN- 0.75 CONN 16 447-PL156 PK - 0.75 447-PL156 PK - 0.75 C4
3463500 A R912-PW1 OR- 16 1
766-PL82 GN- 0.75 M947-PL124 OR- 0.75 T969-PL221 YL - 0.75 973-PL193 BR - 0.75 200-PL143 BK - 0.75 450-PL67 YL - 0.75 450-PL67 YL - 0.75 C5
A 122-PL416 BU - 3.00 PL-C47 CONNECTS TO PL-C64 B 762-PW2 YL - 16 2
T970-PL217 GY- 0.75 G761-PL140 YL - 0.75 976-PL98 OR- 0.75 200-PL303 BK - 2.00 452-PL139 PU - 0.75 452-PL139 PU - 0.75 C6
B 614-PL308 PU - 0.75 1237615 VOL 1 LOC C-8 C
CONN 7 A305-PL363 YL - 0.75 M948-PL105 BR - 0.75 M948-PL209 BR - 0.75 T971-PL222 OR- 0.75 977-PL192 YL - 0.75 1
200-PL322 BK - 2.00 521-PL307 YL - 0.75 521-PL307 YL - 0.75 C7
C C568-PL418 WH- 3.00 C510-PL11 WH - 0.75 M948-PL107 BR - 0.75 T972-PL219 GN- 0.75 G762-PL141 BR - 0.75 507-PL114 WH- 0.75 200-PL381 BK - 3.00 552-PL54 WH- 0.75 552-PL54 WH- 0.75 C8
CONNECTS TO AC-C7 D 519-PL15 PK - 0.75 (19) REAR WASHER MOTOR
C568-PL418 WH - 3.00 A119-PL37 YL - 0.75 H3 200-PL76 BK - 0.75 2
MOTOR
375-5475 200-PL396 BK - 3.00 568-PL236 GN- 0.75 C9
VOL 2 LOC B-6 E C568-PL419 WH- 3.00 C568-PL419 WH - 3.00 M962-PL269 YL - 0.75 M962-PL269 YL - 0.75 G763-PL113 PU - 0.75 C704-PL251 GY- 0.75 202-PL92 BK - 0.75 C10
OR F C743-PL55 PK - 0.75 M963-PL170 BU - 0.75 M963-PL170 BU - 0.75 C707-PL252 PK - 0.75 202-PL299 BK - 1.00 585-PL199 YL - 0.75 C11
CONNECTS TO KV-C7 G 515-PL40 GY- 0.75 E711-PL273 OR- 0.75 R762-PL81 GY- 1.00 G768-PL121 GN- 0.75 C720-PL271 BU - 0.75
RETURN TO DIG (LOADER) (PL) - ATCH 202-PL345 BK - 1.00 C12
VOL 3 LOC H-8
H 200-PL381 BK - 3.00 E917-PL224 WH - 0.75 C743-PL207 PK - 0.75 309-PL10 GY- 0.75 743-PL278 PU - 0.75 743-PL278 PU - 0.75 D1
J
K
124-PL306 GN- 0.75
200-PL396 BK - 3.00
E918-PL223 GN- 0.75
F420-PL225 GN- 0.75
R763-PL80 BU - 1.00 H735-PL180 GY- 0.75 C789-PL247 YL - 0.75
E701-PL270 PK - 0.75
310-PL295 PU - 0.75
314-PL260 PU - 3.00
751-PL230 GN- 0.75
752-PL211 YL - 0.75
751-PL230 GN-
752-PL211 YL -
0.75
0.75
D2
D3
VOLUME 1
PL-C46 PL-C52
F711-PL239 YL - 0.75 R912-PL227 OR- 1.00 R912-PL227 OR- 1.00 G956-PL66 BU - 0.75 CONN 11 754-PL212 BU - 0.75 754-PL212 BU - 0.75 123-PL118 WH- 1.00 D4
F712-PL242 GN- 0.75 T907-PL178 GN- 0.75 T907-PL178 GN- 0.75 H801-PL4 PU - 0.75 F711-PL276 YL - 0.75 2458025 1519276
CONNECTS TO LN-C2 321-PL103 BR - 0.75 766-PL189 GN- 0.75 766-PL189 GN- 0.75 D5
CONN 18 IDENT PART NO. CHG DESCRIPTION NOTE
G423-PL244 PK - 0.75 T969-PL221 YL - 0.75 T969-PL221 YL - 0.75 H801-PL201 PU - 0.75 F712-PL277 GN- 0.75 123-PL354 WH- 1.00 1
VOL 2 LOC I-12 322-PL294 GY- 0.75 900-PL228 PU - 0.75 900-PL228 PU - 0.75 D6
CONNECTS TO EF-C26
H466-PL56 BU - 0.75
H771-PL145 BR- 1.00 T970-PL399 GY- 0.75 T970-PL217 GY- 0.75
H801-PL117 PU - 0.75 F748-PL206 WH- 0.75
G760-PL135 WH- 0.75
G703-PL390 GN- 0.75 2
3
NOTE K PL-C64 367-PL379 BU - 0.75
902-PL232 BR - 0.75
903-PL231 GY- 0.75
902-PL232 BR -
903-PL231 GY-
0.75
0.75
D7
D8 VOL 3 LOC F-4 HARNESS AS.
J878-PL69 YL - 0.75 T970-PL400 GY- 0.75 H802-PL159 GY- 0.75 H802-PL111 GY- 0.75 G761-PL140 YL - 0.75 P832-PL282 WH- 0.75 4 265-PL112 BK- 0.75 2698222 384-PL13 BU - 3.00 975-PL229 WH- 0.75 975-PL229 WH- 0.75 D9
J878-PL292 YL- 0.75
K906-PL75 GN- 0.75 T971-PL222 OR- 0.75 T971-PL222 OR- 0.75
H802-PL220 GY- 0.75 G762-PL141 BR - 0.75
G768-PL121 GN- 0.75 H735-PL180 GY- 0.75
5
6 200-PL350 BK - 0.75 200-PL350 BK - 0.75
R912-PL347 OR- 0.75
762-PL356 YL - 0.75
A
B
CONN 16
CONNECTS TO PW-C2 384-PL68 BU - 3.00
997-PL304 OR- 0.75 D10
D11
HJ 452-0238 01 REAR AUX (8TH FUNCTION) J
M719-PL27 GN- 1.00 H904-PL110 GY- 0.75 G763-PL113 PU - 0.75 200-PL349 BK - 0.75 200-PL349 BK - 0.75 200-PL355 BK - 0.75 C VOL 1 LOC D-8 D12
M721-PL64 WH - 1.00 T972-PL148 GN- 0.75 T972-PL219 GN- 0.75 H735-PL180 GY- 0.75
PL-C40
404-PL245 YL - 0.75 A122-PL226 YL - 0.75 E1 HK 452-0237 01 REAR AUX (HORN ONLY)
M936-PL287 BR - 0.75 T972-PL401 GN- 0.75 H801-PL201 PU - 0.75 200-PL330 BK - 1.00 405-PL122 GY- 0.75 E2
2458025
PL-C13
M937-PL300 GN- 0.75
R762-PL81 GY- 1.00 T993-PL46 BR - 0.75 T993-PL46 BR - 0.75 J764-PL263 BR - 0.75
J764-PL6 BR - 0.75
J764-PL97 BR - 0.75
H802-PL111 GY- 0.75
H904-PL110 GY- 0.75 J764-PL127 BR - 0.75 1
CONN 10
200-PL12 BK - 0.75
200-PL342 BK - 0.75 200-PL355 BK - 0.75 PL-C15
420-PL316
439-PL288
OR- 0.75
YL - 0.75
C216-PL250 BK - 0.75 X977-PL423 YL - 1.00
450-PL67 YL - 0.75
E3
E4 PL 430-5013 03 PLATFORM
4580606 R763-PL80 BU - 1.00 T993-PL48 BR - 0.75 T993-PL48 BR - 0.75 J764-PL362 BR - 0.75 J764-PL97 BR - 0.75 200-PL104 BK - 0.75 2 2458025 441-PL38 OR- 0.75 E455-PL246 BR - 0.75 E455-PL246 BR - 0.75 E5
A1
R912-PL227 OR- 1.00 X800-PL373 OR- 0.75 X800-PL373 OR- 0.75 J764-PL127 BR - 0.75 J878-PL210 YL - 0.75
P993-PL151 OR- 0.75
N939-PL359 GN- 0.75
976-PL98 OR- 0.75
3
4
CONNECTS TO RK-C1
VOL 2 LOC B-12
762-PL356 YL - 0.75 R912-PL348 OR- 0.75 1
2
FLOAT DETENT 447-PL156
452-PL139
PK - 0.75
PU - 0.75
E543-PL214 WH- 0.75 309-PL10 GY- 0.75 E6
E7
PW 387-6692 01 RETURN TO DIG (LOADER) (PL) (WITH LOCKS) G,J
C A2
A3
A4
J878-PL2 YL- 0.75
J878-PL14 YL - 0.75
R908-PL20 YL - 0.75
T993-PL102 BR - 0.75
X800-PL185 OR- 0.75 5
6
NOTE U
R912-PL347 OR- 0.75
762-PL356
200-PL349
YL - 0.75
BK - 0.75
3
4
RTD DETENT
GND
(1) LOADER JOYSTICK BASE
382-4996
515-PL40
518-PL44
GY- 0.75
OR- 1.00
E544-PL215 GN- 0.75
442-PL195 GY- 0.75
E8
E9 PW 387-6694 03 RETURN TO DIG (LOADER) (PL) (WITHOUT LOCKS) G,J C
A5
J878-PL24 YL - 0.75 X800-PL408 OR- 0.75 R912-PL227 OR- 1.00 R912-PL348 OR- 0.75 5 519-PL15 PK - 0.75 E711-PL273 OR- 0.75 L740-PL188 BR - 0.75 E10
A6
A7
J878-PL69 YL - 0.75
J878-PL292 YL - 0.75
J878-PL210 YL - 0.75
J878-PL296 YL - 0.75
Y973-PL57 WH- 0.75
Y974-PL39 BU - 0.75 PL-C1
200-PL350 BK - 0.75 6 GND 521-PL307 YL - 0.75
E747-PL249 BK - 0.75
420-PL324 OR- 0.75
439-PL70 YL - 0.75
E11
E12 STRAP AS.
J878-PL382 YL - 0.75 3463497 568-PL236 GN- 0.75 F1
A8
A9
J878-PL328 YL - 0.75 611-PL51 PU - 1.00
200-PL353 BK - 2.00
A
B CONN 9 RETURN TO DIG - (PLATFORM) 585-PL199
607-PL129
YL -
PK -
0.75
1.00
E900-PL182 WH- 0.75
E901-PL183 GN- 0.75
E900-PL182 WH- 0.75
E901-PL183 GN- 0.75
F2
F3
EW 389-5678 01 STRAP - ECM TO ECM GROUND
A10 105-PL235 RD- 1.00
N939-PL359 GN- 0.75 111-PL241 RD- 1.00 619-PL293 GN- 1.00 C CONNECTS TO FR-C1 608-PL153 GN- 1.00 E917-PL224 WH- 0.75 F4
A11 202-PL144 BK - 0.75
A12 308-PL59 YL - 0.75 102-PL1 RD- 2.00 618-PL335 YL - 0.75 D VOL 2 LOC A-5 617-PL340 BR - 0.75 F5
B1 200-PL136 BK - 1.00 P832-PL282 WH- 0.75 102-PL17 RD- 2.00 606-PL50 GY- 0.75 E 618-PL337 YL - 0.75 E918-PL223 GN- 0.75 F6
105-PL150 RD- 0.75 PL-C71 743-PL278 PU - 0.75 F7
B2 614-PL155 PU - 0.75 2458026
B3 450-PL33 YL - 0.75 P993-PL151 OR- 0.75 115-PL190 RD- 1.00 CONN 15 997-PL304 OR- 0.75 F420-PL225 GN- 0.75 F8
118-PL388 GY- 2.00 PL-C65 143-PL404 BR - 1.00 1 F9
B4 143-PL21 BR - 1.00 2698222 CONNECTS TO PV-C1 H5
B5 F420-PL225 GN- 0.75 R908-PL20 YL - 0.75 123-PL79 WH- 1.00 200-PL342 BK - 0.75 2 A122-PL226 YL - 0.75 F711-PL406 YL - 0.75 F711-PL406 YL - 0.75 F10
123-PL354 WH- 1.00 F711-PL99 YL - 0.75 A VOL 2 LOC I-5 A305-PL53 YL - 0.75 F712-PL346 GN- 0.75 F712-PL346 GN- 0.75 F11
B6 158-PL255 BR - 1.00 (22) CAN DATA LINK RESISTOR 2
B7 157-PL256 YL - 1.00 R912-PL227 OR- 1.00 R912-PL227 OR- 1.00 161-PL30 RD- 1.00 F712-PL100 GN- 0.75 B
134-2540 C216-PL250 BK - 0.75 F761-PL45 BR - 0.75 F761-PL45 BR - 0.75 F12
B8 441-PL38 OR- 0.75 200-PL12 BK - 0.75 C C510-PL11 WH- 0.75 G423-PL244 PK - 0.75 G1
B9 116-PL257 BR - 1.00 T993-PL46 BR - 0.75 T993-PL102 BR - 0.75 200-PL104 BK - 0.75 C568-PL418 WH- 3.00 G2
B10 117-PL258 YL - 1.00 T993-PL48 BR - 0.75 T993-PL407 BR - 0.75 200-PL330 BK - 1.00 C568-PL419 WH- 3.00 H466-PL56 BU - 0.75 304-PL29 WH- 3.00 G3
447-PL156 PK - 0.75 200-PL349 BK - 0.75 E543-PL214 WH- 0.75

B11
PL-C23 (13) PILOT LOADER JOYSTICK (12) MECH LOADER JOYSTICK
J878-PL292 YL - 0.75 X800-PL16 OR- 0.75 200-PL350 BK - 0.75 136-PL357 GN- 1.00 E544-PL215 GN- 0.75 H705-PL149 BR - 0.75 H705-PL149 BR - 0.75
B12
3463501 387-6561 387-6655
C1
X800-PL408 OR- 0.75 200-PL405 BK - 2.00 143-PL404 BR - 1.00 766-PL133 GN- 0.75 E711-PL273 OR- 0.75 H801-PL4 PU - 0.75 H801-PL4 PU - 0.75
X800-PL185 OR- 0.75 202-PL65 BK - 0.75 200-PL12 BK - 0.75 A119-PL364 YL - 0.75 A119-PL364 YL - 0.75 A AUX CTRL +5V SUPPLY E747-PL63 BK - 0.75 J764-PL362 BR - 0.75 J764-PL362 BR - 0.75 PL-C45 PL-C44
C2
X800-PL373 OR- 0.75 202-PL370 BK - 2.00 200-PL330 BK - 1.00 A119-PL375 YL - 0.75 T993-PL407 BR - 0.75 B AUX CTRL RETURN E747-PL249 BK - 0.75 J832-PL326 YL - 0.75 J832-PL326 YL - 0.75 3463500 3463510
C3
C4 630-PL275 GY- 1.00 307-PL163 OR- 0.75 200-PL342 BK - 0.75 A907-PL120 BU - 0.75 Y973-PL57 WH- 0.75 C AUX CTRL SIG 1 (ANALOG) E917-PL224 WH- 0.75 J878-PL296 YL - 0.75 J878-PL296 YL - 0.75 A
C5 106-PL169 RD- 0.75 Y973-PL57 WH- 0.75 308-PL94 YL - 0.75 G956-PL66 BU - 0.75 Y974-PL39 BU - 0.75 D AUX CTRL SIG 2 (ANALOG) E918-PL223 GN- 0.75 J879-PL237 GN- 0.75 J879-PL237 GN- 0.75 105-PL150 RD- 0.75 B
C6 144-PL389 GN- 1.00 308-PL108 YL - 0.75 200-PL349 BK - 0.75 H904-PL110 GY- 0.75 G956-PL66 BU - 0.75 E FNR PWM SIGNAL 1 F420-PL225 GN- 0.75 J984-PL36 PK - 0.75 J984-PL36 PK - 0.75 314-PL260 PU - 3.00 C 314-PL371 PU- 3.00
Y974-PL39 BU - 0.75 320-PL166 OR- 0.75 H904-PL110 GY- 0.75 G423-PL244 PK - 0.75 K906-PL75 GN- 0.75 K906-PL75 GN- 0.75 202-PL101 BK - 0.75
(HANDLE)
(HANDLE)
F FNR PWM SIGNAL 2 D
C7 R762-PL81 GY- 1.00
450-PL67 YL - 0.75 200-PL350 BK - 0.75 J764-PL6 BR - 0.75 J878-PL382 YL - 0.75 G DIFF LOCK SW RETURN DIFF LOCK SW COM G962-PL177 OR- 0.75 L740-PL188 BR - 0.75 L740-PL188 BR - 0.75 123-PL262 WH- 1.00 E 123-PL372 WH- 0.75
C8 R763-PL80 BU - 1.00
C9 307-PL163 OR- 0.75 537-PL318 GN- 0.75 202-PL345 BK - 1.00 J878-PL14 YL - 0.75 J764-PL6 BR - 0.75 H FNR PWM RETURN H466-PL56 BU - 0.75 M739-PL35 YL - 0.75 M739-PL35 YL - 0.75 123-PL118 WH- 1.00 F
C10 607-PL129 PK - 1.00 552-PL54 WH- 0.75 453-PL274 PK - 0.75 J878-PL382 YL - 0.75 J878-PL14 YL - 0.75 J XMSN NEUTRALISER SW RETURN NEUT SW COM K906-PL75 GN- 0.75 M936-PL287 BR - 0.75 K906-PL75 GN- 0.75 G
C11 608-PL153 GN- 1.00 601-PL42 GY- 2.00 766-PL133 GN- 0.75 T993-PL407 BR - 0.75 766-PL133 GN- 0.75 K XMSN NEUTRALISER SW N/O NEUT SW N/O M936-PL287 BR - 0.75 304-PL29 WH- 3.00 H
CONN 8 C12 133-PL47 OR- 0.75 607-PL325 PK - 1.00 A119-PL364 YL - 0.75 Y973-PL57 WH- 0.75 A119-PL375 YL - 0.75 L FNR PWM +5V SUPPLY M937-PL300 GN- 0.75 M937-PL300 GN- 0.75 743-PL278 PU - 0.75 J
CONN 17
CONNECTS TO RH-C12 D1 620-PL280 WH- 1.00 608-PL268 GN- 1.00 A119-PL375 YL - 0.75 Y974-PL39 BU - 0.75 A907-PL120 BU - 0.75 M DIFF LOCK SW N/O DIFF LOCK SW N/O M947-PL196 OR- 0.75 K
IF ANTI-THEFT KEYPAD IS INSTALLED
VOL 3 LOC D-10 D2 C510-PL11 WH- 0.75 614-PL248 PU - 0.75 A907-PL120 BU - 0.75 M948-PL209 BR - 0.75 M962-PL269 YL - 0.75
REMOVE JUMPER AND CONNECT TO AT-C1
B OR
CONNECTS TO CF-C9
D3
D4
568-PL236 GN- 0.75
H771-PL145 BR - 1.00
766-PL189 GN- 0.75
F711-PL31 YL - 0.75 3RD FUNCTION - ATCH
M962-PL269 YL - 0.75
M963-PL170 BU - 0.75 T907-PL178 GN- 0.75 VOL 2 LOC B-5 B
F711-PL95 YL - 0.75 H4 F712-PL387 GN- 0.75 FNR DUTY CYCLE P832-PL403 WH- 0.75
VOL 3 LOC H-10 D5 310-PL295 PU - 0.75 PWM SIGNAL PL-C11
D6 R912-PL227 OR- 1.00 F711-PL406 YL - 0.75 G956-PL66 BU - 0.75 F N R T969-PL221 YL - 0.75 (15) AIR SEAT MOTOR
F712-PL96 GN- 0.75 H904-PL110 GY- 0.75 PL-C54 PL-C39 T907-PL178 GN- 0.75 2458026 433-4804 (VINYL) (CP)
D7 309-PL10 GY- 0.75 3463499 3463509 SIGNAL 1 90% 50% 10% (18) HEATED AIR SEAT MOTOR
F712-PL346 GN- 0.75 J764-PL6 BR- 0.75 T969-PL221 YL - 0.75 T970-PL217 GY- 0.75 180-PL261 GN- 2.00 1 433-4805 (FABRIC) (CP) CONNECTS TO PL-C11
D8 405-PL122 GY- 0.75 MOTOR MOTOR 395-2942 (CP)
G703-PL390 GN- 0.75 J878-PL14 YL - 0.75 136-PL357 GN- 1.00 A T970-PL217 GY- 0.75 200-PL272 BK - 2.00 2 433-4808 (FABRIC) (SS) VOL 1 LOC B-5
D9 452-PL139 PU - 0.75 SIGNAL 2 90% 50% 10% 469-7056 (SS)
H801-PL4 PU - 0.75 J878-PL382 YL - 0.75 A907-PL120 BU - 0.75 B A907-PL61 BU - 0.75 T971-PL222 OR- 0.75 T971-PL222 OR- 0.75 433-4806 (DELUXE) (CP)
D10 G423-PL244 PK - 0.75 433-4809 (DELUXE (SS)
D11 439-PL288 YL - 0.75 J764-PL362 BR - 0.75 R908-PL20 YL - 0.75 R908-PL20 YL - 0.75 C T972-PL219 GN- 0.75
D12 E918-PL223 GN- 0.75 J878-PL296 YL - 0.75 R912-PL227 OR- 1.00 202-PL345 BK - 1.00 D T972-PL219 GN- 0.75
N939-PL359 GN- 0.75 T993-PL407 BR - 0.75 F711-PL31 YL - 0.75 E CONN 14 X977-PL243 YL - 1.00
E1 E917-PL224 WH- 0.75
P832-PL282 WH- 0.75 Y973-PL57 WH- 0.75 F712-PL387 GN- 0.75 F IF AWS IS INSTALLED REMOVE JUMPER AND X977-PL422 YL - 1.00 X800-PL16 OR- 0.75 X800-PL16 OR- 0.75
E2 420-PL316 OR- 0.75
E3
X800-PL16 OR- 0.75 Y974-PL39 BU - 0.75 453-PL274 PK - 0.75 G CONNECT PL-C54 TO WP-C1 X977-PL423 YL - 1.00 X977-PL423 YL - 1.00 X977-PL423 YL - 1.00
H VOL 2 LOC E-15
E4 131-PL395 BR - 1.00
E5
E6
M719-PL27 GN- 1.00
M721-PL64 WH- 1.00
PL-C36 WIRE GROUP COLOR DESCRIPTIONS
H3 H3 2458026
E7 (37) TRANSMISSION HANDLE NEUTRAL SWITCH
766-PL189 GN- 0.75 1 263-7261 GROUND CIRCUIT
E8 A305-PL363 YL - 0.75
E9 H466-PL56 BU - 0.75 J878-PL296 YL - 0.75 2 WIRES THAT HAVE SYSTEM VOLTAGE WHEN THE KEY SWITCH IS OFF
E10 M936-PL287 BR - 0.75 H4 H4
WIRES THAT HAVE SYSTEM VOLTAGE WHEN THE KEY SWITCH IS ON
E11 M937-PL300 GN- 0.75
E12 603-PL377 PK - 1.00 STARTING CIRCUIT
605-PL172 YL - 0.75 H5 H5
F1 START AID CIRCUIT
F2 606-PL171 GY- 0.75
MACHINE CONTROL CIRCUIT
F3 161-PL179 RD- 1.00
F4 159-PL317 BU - 1.00 AWD CIRCUIT
F5 518-PL44 OR- 1.00 HEATER AND AIR CONDITIONER CIRCUIT
F6 537-PL323 GN- 0.75 CALLOUTS TURN SIGNAL / WIPER WASHER CIRCUIT
F7 202-PL92 BK - 0.75
F8 404-PL245 YL - 0.75 CAN DATA LINK
F9
F10
Callout Number Component
F11 E711-PL273 OR- 0.75
(Machine Location from (52) VALVE GP - CONTROL Name OTHER COLOR DESCRIPTIONS
Component Locations Table)
F12 453-PL274 PK - 0.75 138-1234 Part Number
G1 HIGHWAYS
G2
A G3
G4
A
G5
G6
G7
THIS SCHEMATIC IS FOR THE 420F2, 428F2, 430F2, 432F2, 434F2 AND 444F2 BACKHOE LOADER ELECTRICAL SYSTEM
G8
G9 VOLUME 1 of 3: CAB
G10
G11
G12
MEDIA NUMBER: UENR5149-01
SCHEMATIC PART NUMBER: 417-4234, CHANGE: 00, VERSION: S
Components are shown installed on a fully operable machine with the key and engine off, transmission shifter
in neutral and with parking brake set.
Refer to the appropriate Service Manual for Troubleshooting, Specifications and Systems Operations.
Refer to the Parts Manual using a specific serial number prefix in SIS before ordering parts from this schematic.
16 15 14 13 12 11 10 9 8 7 6 5 4 3 2 1
UENR5149-01
January 2018
108
112
54 73 74 53 CONN 26 60
121

CONN 24
68 82
FRONT AXLE 78
120 CONN 1
CONN 52
CONN 2
CONN 3 420F2, 428F2, 430F2, 432F2,
CONN 33 CONN 29 434F2 and 444F2 Backhoe Loader
95
Electrical System
79 420F2: 428F2: 430F2: 432F2:
88 LYB1-546 LYG1-1833 LYD1-194 LYJ1-582
CONN 25 B LYC1-444 LYE1-202
83
CONN 14 LBS1-457
89
42 Page,
VIEW OF AREA “B” 434F2: 444F2:
LYK1-328 LYL1-360
124
CONN 35
Volume 2 of 3: Chassis
69 61 107 80 106 105 57 99 58 87 93 94
© 2018 Caterpillar, All Rights Reserved Printed in U.S.A.
OBJECT HANDLING WIRING AWS WIRING REAR VALVE AND FRAME WIRING
CONN 24 CONN 136
113
CONN 36
59
63 Symbols
MANUAL SHIFTER
RIGHT HAND CONSOLE T
CONN 38 Pressure Temperature Level Flow Circuit Breaker

Symbol Symbol Symbol Symbol Symbol
Component Location (Volume 2)
147 Com ponent

Schem atic Machine
Com ponent
Schem atic Machine Symbols and Definitions
Location Location Location Location
Alarm - Backup G-16 53 Suppressor - Quick Coupler Arc #4 B-13 101 Fuse: A component in an electrical circuit that will open the circuit if too much current flows
Connector Location
CONN 10 Control - AWS
Control - Product Link (PL631, Cellular Radio)
D-13
E-5
54
55
Suppressor - Quick Coupler Arc #5
Suppressor - Ride Control Arc
B-13
C-10
102
103 Connector Num ber
Schem atic
Location
through it.
Control - Product Link (PL641, Cellular Radio) D-5 149 Suppressor - Side Shift (Left) G-12 105 CONN 1 I-13 Switch (Normally Open): A switch that will close at a specified point (temp, press, etc.). The
CONN 32 148 Diode - Blocking #2

Diode - Side Shift #1
H-12
F-12
56
57
Suppressor - Side Shift (Right)
Suppressor - Side Shift Lock (SS Only)
G-12
H-15
106
107
CONN 2 H-13 circle indicates that the component has screw terminals and a wire can be disconnected from it.
CONN 3 G-9
Diode - Side Shift #2 F-12 58 Sw itch - AWS Mode D-15 108 CONN 6 C-1 Switch (Normally Closed): A switch that will open at a specified point (temp, press, etc.).
Ground - Cab RF F-1 59 Sw itch - Blow er Speed B-8 109 CONN 7 B-6 No circle indicates that the wire cannot be disconnected from the component.
Handle - Operator (7th Function, E-Stick) J-15 60 Sw itch - Broom Angle A-16 110
CONN 9 A-5
126 Horn - Rear
Motor - Blow er
G-16
A-8
61
62
Sw itch - Continuous Flow
Sw itch - Crab Circle
A-16
D-15
111
112
CONN 10
CONN 11
B-12
I-12
Ground (Wired): This indicates that the component is connected to a grounded wire. The
Motor - Face Fan 1 H-5 147 Sw itch - Door H-3 113 grounded wire is fastened to the machine.
CONN 12 A-13
133 CONN 37 Motor - Face Fan 2
Motor - Wiper Assembly (Rear)
H-5
E-3
148
63
Sw itch - External Pow er
Sw itch - Float Detent
B-15
H-9
114
115
CONN 13 B-5
CONN 14 E-15
It is grounded by being fastened to the machine.
125 CONN 40 CONN 41 Port - Pow er #2

Relay - Antitheft #1
J-5
C-4
64
65
Sw itch - HBCV Detent
Sw itch - Heater A/C
C-6
B-8
116
117
CONN 15
CONN 17
I-5
B-5
Relay - Antitheft #2 B-4 66 Sw itch - Loader Quick Coupler Pins B-15 118 CONN 19 J-8, G-8 Reed Switch: A switch whose contacts are controlled by a magnet. A magnet closes the
Resistor - Motor Speed A-8 67 Sw itch - Return To Dig I-3 119 contacts of a normally open reed switch; it opens the contacts of a normally closed reed switch.
CONN 20 J-8, H-8
Sensor - Axle Position (Front) C-16 68 Sw itch - Stability Pressure F-6 120 CONN 21 D-9
Sensor - Axle Position (Rear) C-10 69 Sw itch - Stability Warning E-10 121
64 Sensor - Ride Control
Sensor - Stabilizer Leg (LH)
B-10
G-15
72
73
Sw itch - Thermostat
Sw itch - Vent
A-8
B-7
122
123
CONN 24
CONN 25
E-12, C-9, C-8
C-15
T
Sender: A component that is used with a temperature or pressure gauge. The sender
measures the temperature or pressure. Its resistance changes to give an indication to
CONN 26 F-15 the gauge of the temperature or pressure.
CONN 20 Sensor - Stabilizer Leg (RH)
Solenoid - HBCV
F-15
C-6
74
77
Valve - AWS
Transm ission (Manual)
E-9 124 CONN 27 A-13
CONN 21 Solenoid - Hoe Auxiliary Valve #1 (7th Function) J-15 78 Diode - Reverse Solenoid I-6 125
CONN 28
CONN 29
A-11
F-13
It has a coil that makes an electromagnet when current flows through it. The
CONN 19 Solenoid - Hoe Auxiliary Valve #2 (7th Function) J-15 79 Sensor - Converter Temperature I-6 126 CONN 30 A-9 electromagnet can open or close the switch part of the relay.
77 CONN 121 Solenoid - Implement Lockout (SS Only)

Solenoid - Load Sense Dump Valve
H-15
J-10
80
N/A
Sensor - Pump Discharge Pressure
Sensor - XMSN Speed (Out)
I-8
I-8
127
128
CONN 31
CONN 32
A-9
C-8
Solenoid: A solenoid is an electrical component that is activated by electricity. It has a
Solenoid - Loader Auxiliary Valve #1 (SS Only) I-15 82 Solenoid - AWD J-6 129 CONN 33 E-8
Solenoid - Loader Auxiliary Valve #2 (SS Only) I-15 83 Solenoid - Differential Lock J-6 130 coil that makes an electromagnet when current flows through it. The electromagnet
CONN 34 Service Connector E-6
Solenoid - Loader Quick Coupler A-12 84 Solenoid - Forw ard (Low ) I-6 131 can open or close a valve or move a piece of metal that can do work.
55 Solenoid - Lock Valve (LH) I-10 85 Solenoid - Hydraulic Torque Limit J-8 132
CONN 35 E-7
127 Solenoid - Lock Valve (RH) I-10 86 Solenoid - Reverse J-6 133
CONN 36
CONN 37
C-3
G-5, H-5, D-1 Magnetic Latch Solenoid: A magnetic latch solenoid is an electrical component that is
116 Solenoid - Lockout
Solenoid - Pattern Changer #1 (SS Only)
G-12
I-15
87
88
Transm ission (Autoshift)
Sensor - Converter Temperature F-6 134
CONN 38
CONN 39
J-5,G-3, H-3
I-4
that make electromagnet when current flows through them. It also has an internal switch that places
132 149 Solenoid - Pattern Changer #2 (SS Only)

Solenoid - Return To Dig Loader Detent
I-15
I-4
89
90
Sensor - Pump Discharge Pressure
Sensor - XMSN Speed (Out)
G-8
G-8
135
136
CONN 40 J-5, D-1 the latch coil circuit open at the time the coil latches.
131 Solenoid - Ride Control #1 B-10 91 Solenoid - AWD H-6 137

CONN 41
CONN 52
J-3
D-12 Harness and Wire Symbols
Solenoid - Ride Control #2 B-10 92 Solenoid - Differential Lock H-6 138 CONN 121 D-9
Solenoid - Side Shift (Left) G-12 93 Solenoid - Forw ard (High) G-6 139 Wire, Cable, or Harness Harness Identification Letter(s):
128 CONN 13 Solenoid - Side Shift (Right)

Solenoid - Side Shift Lock (SS Only)
G-12
H-15
94
95
Solenoid - Forw ard (Low )
Solenoid - Hydraulic Torque Limit
F-6
I-6
140
141
CONN 136 C-3, E-1
The connectors show n in this chart are for harness to
Assembly Identification: Includes
Harness Identification Letters and
(A, B, C, ..., AA, AB, AC, ...)
harness connectors. Connectors that join a harness to a Harness Connector Serialization Code:
Suppressor - Arc (Return To Dig) I-4 96 Solenoid - Lockup Clutch H-6 142 component are generally located at or near the The "C" stands for "Connector" and the
Codes (see sample).
Suppressor - Load Check Disable #1 I-10 97 Solenoid - Reverse G-6 143 number indicates which connector in the
component. See the Component Location Chart.
66 Suppressor - Load Check Disable #2
Suppressor - Lockout Solenoid
H-9
F-12
98
99
Solenoid - Speed Clutch #1
Solenoid - Speed Clutch #2
H-6
G-6
144
145
AG-C4
111-7898
L-C12
3E-5179
L-C12
3E-5179
harness (C1, C2, C3, ...).
91 Suppressor - Quick Coupler Arc #3 B-13 100 Solenoid - Speed Clutch #3 G-6 146
Part Number: for Connector Plug 1
92 65 2
72 Plug Receptacle
103 CONN 17 1 Deutsch connector: Typical representation
5A
Component
of a Deutsch connector. The plug contains all Fuse (5 Amps) 9X-1123 Part Number
2
130 CONN 6 sockets and the receptacle contains all pins.
325-AG135 PK-14
1 Sure-Seal connector: Typical representation Harness identification code:
of a Sure-Seal connector. The plug and receptacle This example indicates wire group 325, Wire Gauge
2 contain both pins and sockets. wire 135 in harness "AG". Wire Color
129 CONN 34 CONN 9
MANUAL XMSN WIRING RIDE CONTROL WIRING HEADLINER AND ATTACHMENT WIRING
140 118 111 114 110
143
DASH
119
146
117 109
LIFT ARM
137
123
86
134
CONN 39 98
144 56 122 67
142 CONN 31 102 101 CONN 11 62

100 CONN 7
136 84
115
VIEW OF AREA “C” RH FRAME
(ROTATED FOR CLARITY)
C CONN 20
CONN 19
135
85
141
97
145
139 CONN 27
CONN 28
138 CONN 15 96
CONN 30 CONN 12 90
AUTOSHIFT XMSN WIRING FRONT QUICK COUPLER WIRING RETURN TO DIG (SINGLE TILT) WIRING LOAD CHECK DISABLE WIRING HVAC WIRING
16 15 14 13 12 11 10 9 8 7 6 5 4 3 2 1
XK-C3 CONN 38 CABLE AS

ANTENNA
3463513 HM-C1 8E-1118
XK-C9 TO DOOR SWITCH HARNESS 3463506 101-2640
A 1552269 CONNECTS TO XF-C8
B LOCATED AT H-3 A 123-HM101 WH- 0.75
(60) OPERATOR RIGHT HANDLE RT-C2 H705-XK5 BR - 18 1 (132) HYD TORQUE LIMIT SOL STD B 200-HM14 BK - 1.00
C
387-6566 3463501 J879-XK3 GN- 18 2 341-7630 OR C 115-HM7 RD- 1.00 161-HM104 RD- 1.00 RADIO
D 552-XK4 WH- 18
5V POWER A 997-RT43 OR - 0.75 D NOTE G
5V RETURN B T993-RT45 BR - 0.75
E 324-XK14 BU- 18 CONN 40 161-HM26 RD- 1.00
200-HM18 BK - 0.75
262-2781 (AM/FM/CD)
F 754-XK12 BU- 18 387-6604 (AM/FM/CD/BLUETOOTH)
ROLLER SIGNAL 1 C M962-RT39 YL - 0.75 TO INTERNAL ROOF HARNESS 115-HM7 RD- 1.00 DOME LIGHT
G 752-XK9 YL- 18 XK-C1
ROLLER SIGNAL 2 D M963-RT40 BU - 0.75 CONN 20 H 452-XK16 PU- 18 1552269

CONNECTS TO HL-C1 426-0976
HR-C2
ANTENNA
E LOCATED AT D-1 123-HM101 WH- 0.75
CONNECTS TO PL-C16 J 1728037
F 324-XK14 BU - 18 1 (130) DIFFERENTIAL LOCK SOL AS STD
7TH FUNCTION VOL 1 LOC E-5 K 200-XK18 BK- 18
G 200-XK18 BK - 18 2 383-8708 161-HM26 RD- 1.00 161-HM103 RD- 1.00 1
(E-STICK) L F761-XK10 BR - 18
J AESC SW NC
AESC SW NO
H
J
K973-RT6 PK - 0.75
K974-RT15 PU - 0.75
M
N
J879-XK13
H801-XK11
GN- 18
PU - 18
(NOT FITTED ON 444F) SPEAKER LH
262-9567
+
-
508-HM11 PU - 0.75
509-HM12 WH- 0.75
161-HM104 RD- 1.00 2
3 J
AESC SW COMMON K J878-RT23 YL - 0.75 200-HM14 BK - 1.00 200-HM18 BK - 0.75 HM-C2 HR-C1 161-HR4 RD- 18 4 +(POS) 12V BTRY
P 200-XK18 BK- 18 XK-C6
L 200-HM17 BK - 1.00 200-HM100 BK - 0.75 2698224 3E3388 5
R 202-XK19 BK- 18 1552269 1
M 509-HM12 WH- 0.75 509-HR1 WH- 18 123-HR5 WH- 18 123-HR8 WH- 18 6 ILLUMINATION
S 202-XK19 BK- 18 324-XK14 BU- 18 2
552-XK4 WH- 18 1 (129) AWD SOL STD 508-HM11 PU - 0.75 508-HM11 PU - 0.75 508-HR2 PU - 18 123-HR9 WH- 18 7 +(POS) 12V IGN
452-XK16 PU- 18
J879-XK8 GN - 18 2 383-8708 509-HM12 WH- 0.75 200-HM100 BK - 0.75 3 200-HR3 BK - 18 200-HR3 BK - 18 8 GROUND
XK-C8 552-XK4 WH- 18
3463511 511-HM9 BR - 0.75 4 9
752-XK9 YL- 18 511-HM9 BR - 0.75 161-HM103 RD- 1.00 5 161-HR4 RD - 18
RT-C3 SPEAKER RH + 512-HM10 GN - 0.75 10
A E900-XK15 WH- 18 754-XK12 BU - 18 - 6
2458026 RT-C1 262-9567 512-HM10 GN - 0.75 123-HM101 WH- 0.75 123-HR5 WH- 18 511-HR7 BR - 18 11 RH SPKR +(POS)
(78) HOE AUX VALVE SOL #1 B E901-XK17 GN - 18 E900-XK15 WH- 18 XK-C5 7
1 T969-RT37 YL - 0.75 3313594 512-HM10 GN- 0.75 512-HR6 GN - 18 512-HR6 GN - 18 12 RH SPKR -(NEG)
362-3212 C H705-XK5 BR - 18 1552269 8
2 H802-RT1 GY- 0.75 511-HM9 BR - 0.75 511-HR7 BR - 18 508-HR2 PU - 18 13 LH SPKR +(POS)
PORT B 1 D E901-XK17 GN- 18
997-RT43 OR- 0.75 X752-XK2 GY - 18 1 (133) REVERSE SOL STD 14 LH SPKR -(NEG)
605-RT3 YL - 0.75 2
CONN 19 E
F761-XK10 BR - 18 2 324-2579 CONN 41 509-HR1 WH - 18
15
3 CONNECTS TO PL-C5 F F761-XK10 BR - 18
200-RT11 BK- 0.75 606-RT9 GY- 0.75 (ET SOL 3) 16
4 VOL 1 LOC E-5 G H705-XK5 BR - 18
RT-C4 200-RT18 BK- 0.75 200-RT31 BK- 2.00 617-RT12 BR- 0.75
5 H H801-XK11 PU - 18 (64) POWER PORT 2 115-HM7 RD - 1.00
2458026 200-RT46 BK- 0.75 367-RT5 BU - 0.75
(79) HOE AUX VALVE SOL #2 6 J J764-XK6 BR- 18 XK-C10 178-7539
1 T971-RT36 OR- 0.75 T993-RT45 BR- 0.75 200-HM17 BK - 1.00
362-3212 7 K X800-XK1 OR- 18 1552269
2 H802-RT10 GY- 0.75 997-RT43 OR- 0.75 M963-RT40 BU- 0.75
PORT A 8 L J764-XK6 BR - 18
C216-RT2 BK - 0.75 604-RT13 OR- 0.75 X752-XK2 GY - 18 1 (125) REVERSE SOL DIODE
9 M J984-XK7 PK - 18 J879-XK13 GN- 18 J879-XK3 GN - 18
E543-RT20 WH- 0.75 R762-RT34 GY- 0.75 754-XK12 BU - 18 2 189-3158
J879-XK8 GN- 18
E-STICK (7TH FUNCTION) - ATCH E544-RT21 GN- 0.75 R763-RT26 BU- 0.75 10 HEADLINER RADIO - ATCH
G962-RT27 OR- 0.75 G962-RT27 OR- 0.75 11
NOTE D 12 J984-XK7 PK- 18 XK-C4
13 (127) PUMP DISCHARGE PRESS SNSR (MANUAL) XK-C7 1552269 SYMBOL DESCRIPTION
H771-RT16 BR- 0.75 H771-RT24 BR- 0.75 200-RT31 BK- 2.00
14 344-7391 2304013 X800-XK1 OR- 18
200-RT46 BK- 0.75 H771-RT19 BR- 0.75 M962-RT39 YL - 0.75 752-XK9 YL- 18 1 (131) FORWARD LOW SOL STD
H802-RT8 GY- 0.75 15 +(POS) V 1 X800-XK1 OR- 18 H801-XK11 PU- 18 2 324-2579 CIRCUIT CONNECTED
H801-RT32 PU- 0.75 H801-RT30 PU- 0.75 321-RT22 BR- 0.75 16 CONN 1 GROUND 2 J764-XK6 BR - 18 (119) RETURN TO DIG SW (ST)
(ET SOL 1) PV-C2 PX-C1
H801-RT33 PU- 0.75 K973-RT6 PK- 0.75 17 CONNECTS TO PL-C26 SIGNAL 3 J984-XK7 PK - 18 206-1486 CIRCUIT NOT CONNECTED
1552267 3E3370
H802-RT1 GY- 0.75 H802-RT8 GY- 0.75
K974-RT15
J878-RT23
PU - 0.75
YL - 0.75
18
19
VOL 1 LOC J-16
XK-C11 143-PV1 BR- 18 A 143-PX1 BR- 16
WIRE GROUP COLOR DESCRIPTIONS ELECTRICAL CONNECTION TO
(128) XMSN OUT SPEED SNSR (MANUAL) MACHINE STRUCTURE
H802-RT10 GY- 0.75 T969-RT37 YL - 0.75 20 LN-C1 XK-C2 2304011 762-PV3 YL - 18 B 762-PX2 YL - 16 GROUND CIRCUIT
21 191-8305 1552269 452-XK16 PU- 18 1 (126) CONVERTER TEMP SNSR C INTERNAL ELECTRICAL CONNECTION
RT-C5 1552269 WIRES THAT HAVE SYSTEM VOLTAGE WHEN THE KEY SWITCH IS OFF TO SURFACE OF COMPONENT
2458026 J878-RT23 YL - 0.75 T971-RT36 OR- 0.75 22 SIG -(NEG) 1 E901-XK17 GN- 18 202-XK19 BK- 18 2 256-6453
I (88) PATTERN CHANGER SOL #1 1 R762-RT35 GY- 0.75 K973-RT6 PK- 0.75
K974-RT15 PU- 0.75 E747-RT17 BK - 0.75
23
24
123-LN2 WH- 18
G703-LN9 GN - 18
1
2
RD-18
BR-18
(85) LH LOCK VALVE SOL
262-7081 SIG +(POS) 2 E900-XK15 WH- 18 T
PV-C1
CONN 39 WIRES THAT HAVE SYSTEM VOLTAGE WHEN THE KEY SWITCH IS ON
CONNECTOR I
240-6866 2 R763-RT25 BU - 0.75 RETURN TO DIG STARTING CIRCUIT
M962-RT39 YL - 0.75 H801-RT30 PU - 0.75 25 3E3364 H#
M963-RT40 BU- 0.75 E543-RT20 WH - 0.75 26 CONN 15 1 143-PV1 BR- 18 143-PV1 BR- 18 (LOADER) (ST) - ATCH MACHINE CONTROL CIRCUIT CIRCUIT GROUPING DESIGNATION
E544-RT21 GN - 0.75 27 CONNECTS TO PL-C71 2 200-PV5 BK- 18 AWD CIRCUIT

200-PV2 BK- 18 ATCH WIRE, CABLE, COMPONENT
RT-C6 R762-RT35 GY- 0.75 R762-RT34 GY- 0.75 C216-RT2 BK- 0.75 28 VOL 1 LOC C-9 HEATER AND AIR CONDITIONER CIRCUIT
200-PV7 BK- 18
2458026 R762-RT38 GY- 0.75 618-RT7 YL - 0.75 29 LN-C4 MANUAL XMSN TURN SIGNAL / WIPER WASHER CIRCUIT SPLICE
1 627-RT28 YL - 0.75 30 LN-C2 1552269 762-PV4 YL - 18
(89) PATTERN CHANGER SOL #2 R762-RT38 GY- 0.75 CAN DATA LINK
2 R763-RT4 BU- 0.75 R763-RT26 BU- 0.75 H771-RT24 BR - 0.75 31 3E3382 123-LN2 WH- 18 123-LN6 WH- 18 1 762-PV6 YL - 18 PV-C3 BLADE, SPADE, RING OR SCREW
240-6866 R763-RT4 BU - 0.75 (97) LOAD CHECK DISABLE SUPPRESSOR #1
R763-RT25 BU- 0.75 1 123-LN17 WH- 18 123-LN17 WH- 18 123-LN3 WH- 18 G703-LN11 GN - 18 2 762-PV3 YL - 18 1552269 ETHERNET TERMINAL
CONN 11 189-3158
2 G703-LN26 GN - 18 123-LN6 WH- 18 762-PV4 YL - 18 1 (90) RTD LOADER DETENT
T969-RT37 YL - 0.75 3 123-LN15 WH- 18 XA-C14
CONNECTS TO PL-C46 200-PV5 BK- 18 2 350-8887
RT-C7 T971-RT36 OR- 0.75 4 P832-LN27 WH- 18 1552269
2458026 T993-RT45 BR- 0.75
VOL 1 LOC C-11
NOTE K 5 G703-LN5 GN- 18 LN-C6 H705-XA26 BR - 18 1 (141) HYD TORQUE LIMIT SOL AUTO OTHER COLOR DESCRIPTIONS
(82) LOADER AUX VALVE #1 1 E543-RT20 WH- 0.75 6 G763-LN14 PU - 18 G703-LN9 GN- 18 1552269 J879-XA25 GN- 18 2 341-7630 ABBREV COLOR
RT-C13 HIGHWAYS
362-3212 2 H801-RT33 PU - 0.75 1519276 G703-LN26 GN- 18 G703-LN10 GN- 18 123-LN15 WH- 18 1 RD-18 (86) RH LOCK VALVE SOL PV-C4
200-RT46 BK- 0.75 G703-LN11 GN- 18 G703-LN10 GN - 18 2 BR-18 262-7081 1552269 RD RED
1 (96) RTD ARC SUPPR
G703-LN12 GN- 18 762-PV6 YL - 18 1 WH WHITE
CONN 2
42 Page,
2 189-3158
3 200-PV7 BK- 18 2
RT-C8 200-RT46 BK - 0.75 CONNECTS TO PL-C34 G763-LN14 PU - 18 XA-C10 OR ORANGE
2458026 321-RT22 BR - 0.75 T907-RT41 GN - 0.75 4 LN-C10 1552269
VOL 1 LOC I-16
(83) LOADER AUX VALVE #2 1 E544-RT21 GN - 0.75 367-RT5 BU - 0.75 X800-RT42 OR - 0.75 5 1552269
GEAR DIAGRAM SOLENOIDS ET SOL J832-XA28 YL - 18 1 (142) LOCKUP CLUTCH YL YELLOW
604-RT13 OR - 0.75 J764-RT14 BR - 0.75 6 LN-C9
362-3212 2 H801-RT32 PU - 0.75
605-RT3 YL - 0.75
(56) BLOCKING DIODE 2 1 G763-LN14 PU - 18 P832-LN27 WH- 18 P832-LN27 WH- 18
1F FWD LOW & CLUTCH 1 1&4
H801-XA10 PU - 18 2 366-1789 RETURN TO DIG (PLATFORM) - ATCH PK PINK
189-3158 2 X997-LN20 BR - 18 X997-LN20 BR - 18 X997-LN20 BR - 18 1552269 NOTE G
606-RT9 GY - 0.75 2F FWD HIGH & CLUTCH 1 2&4
NOTE G
617-RT12 BR - 0.75
123-LN3 WH- 18 1 (98) LOAD CHECK DISABLE SUPPRESSOR #2 BK BLACK
G703-LN12 GN - 18 2 189-3158 3F FWD HIGH & CLUTCH 2 2&5
RT-C9 618-RT7 YL - 0.75 XA-C11 GY GRAY
2458026 627-RT28 YL - 0.75 4F FWD LOW & CLUTCH 3 1&6
1552269
(95) SIDE SHIFT LOCK SOL BK-18 1 H771-RT19 BR - 0.75 NEUT ALL OFF 1
PU PURPLE
XA-C7 324-XA22 BU - 18 (138) DIFF LOCK SOL AS AUTO
257-0478 BK-18 2 200-RT11 BK - 0.75 E747-RT17 BK - 0.75 1R REV & CLUTCH 1 3&4 2
J764-RT14 BR - 0.75 LN-C7
3463513 200-XA29 BK - 18 274-8048 XF-C6
XF-C8
BR BROWN
T907-RT41 GN - 0.75 A 900-XA7 PU - 18 2R REV & CLUTCH 2 3&5 3463506
1552267 3463496 GN GREEN
X800-RT42 OR - 0.75 B 902-XA5 BR - 18 3R REV 7 CLUTCH 3 3&6 A 123-XF5 WH- 0.75
P832-LN27 WH- 18 A BK-18 (115) FLOAT DETENT SW CONN 37 123-XF5 WH- 0.75 A
H RT-C10
2458026
G703-LN5 GN - 18 B
C
RD-18 194-2553 (432F & 444F)
229-8757 (428F & 434F)
C
D
903-XA3 GY- 18
552-XA21 WH- 18 XA-C6
CONNECTS TO HL-C1
B
C
200-XF6
115-XF8
BK - 1.00
RD- 1.00
200-XF7 BK - 1.00 B
CONN 38
CONNECTS TO HM-C1
BU BLUE H
X997-LN20 BR - 18 BU-18 E LOCATED AT D-1 115-XF8 RD- 1.00 C
324-XA22 BU - 18 200-XA29 BK- 18 1552269 D 161-XF9 RD- 1.00 LOCATED AT J-5
(107) SIDE SHIFT LOCK SUPPRESSOR 1 H771-RT16 BR - 0.75 F 161-XF10 RD- 1.00 D
754-XA12 BU - 18 202-XA30 BK- 18 115-XF8 RD - 1.00 115-XF8 RD - 1.00
189-3158 2 200-RT18 BK - 0.75 CONN 20 G 752-XA9 YL- 18 324-XA22 BU- 18 552-XA21 WH- 18 1 (137) AWD SOL AS AUTO
123-XF5 WH - 0.75 123-XF5 WH - 0.75 NOTE DESCRIPTION
CONNECTS TO PL-C16 H J879-XA16 GN- 18 2 274-8034
452-XA18 PU - 18 452-XA18 PU- 18
VOL 1 LOC E-5 J 552-XA21 WH- 18 161-XF3 RD - 1.00 161-XF2 RD - 0.75
K 200-XA29 BK - 18 751-XA1 GN- 18 161-XF9 RD - 1.00 161-XF10 RD - 1.00 NOTE A: ASSEMBLE TERMINALS TO DESIGNATED STUD
RT-C11
2458026 L F761-XA23 BR - 18 752-XA9 YL- 18
LOAD CHECK DISABLE (SS ONLY) - ATCH NOTE G: OPTION BASED ON MACHINE CONFIGURATION
M J879-XA27 GN - 18 754-XA12 BU- 18 200-XF4 BK - 1.00
(80) IMPLEMENT LOCKOUT SOL 1 G962-RT27 OR - 0.75 N NOTE J: ATTACHMENT
H801-XA4 PU - 18 900-XA7 PU- 18 200-XF6 BK - 1.00 200-XF7 BK - 1.00
373-6995 2 C216-RT2 BK - 0.75 XA-C1 (113) DOOR SW
P 902-XA5 BR- 18 (147) FACE FAN 1
1552269 XF-C2 XF-C1 105-8034 NOTE M: FOR MACHINES WITHOUT AIR CON REPLACE HEATER AC SW WITH VENT SW.
R 903-XA3 GY- 18 (144) SPEED CLUTCH 1 SOL 106-1744
751-XA1 GN- 18 1 2458026 1082253
S 202-XA30 BK- 18 274-8034 NOTE S: THERMOSTAT FITTED TO MACHINES WITH AIR CON ONLY.
975-XA13 WH- 18 975-XA2 WH- 18 975-XA2 WH- 18 2 BK-18 1 200-XF4 BK - 1.00
(ET SOL 4) 161-XF2 RD- 0.75 A
975-XA6 WH- 18 PK-18 2 161-XF3 RD- 1.00 NOTE T: WHEN FITTED, CONNECTS TOECT X739-BR TO DOME LIGHT
B
B
REAR VALVE BLOCK (SS ONLY) XA-C8
X739-XF1 BR - 0.75 C
PE-C3 E900-XA20 WH- 18 L
3463511
1552269 H
A E900-XA20 WH- 18 E901-XA19 GN - 18 X739-XF1 BR - 0.75 NOTE T
(93) SIDE SHIFT LEFT SOL 1 M719-PE17 GN- 18 B XA-C3 M
RV-C8 E901-XA19 GN- 18
238-4626 2 200-PE10 BK - 18 1552269
1552267 C H705-XA26 BR - 18 F761-XA23 BR- 18 (145) SPEED CLUTCH 2 SOL
D 975-XA13 WH- 18 H705-XA26 BR- 18 903-XA3 GY- 18 1
(73) CONNECTS TO LH STAB LEG SENSOR
A X800-RV23 OR- 18 CONN 19 E J832-XA28 YL - 18 M739-XA11 YL - 18 2
280-7009
(ET SOL 5)
CALLOUTS
B J764-RV21 BR - 18
387-6626 PE-C6 CONNECTS TO PL-C5 F H801-XA4 PU- 18
C T907-RV26 GN- 18
1552269 VOL 1 LOC E-5 G 751-XA1 GN- 18 H801-XA10 PU- 18 DOOR SWITCH & FACE FAN - ATCH
H H801-XA24 PU- 18 Callout Number Component
(105) SIDE SHIFT LEFT SUPPR 1 M719-PE18 GN- 18 J M739-XA11 YL - 18
(Machine Location from (52) VALVE GP - CONTROL Name
RV-C2 189-3158 2 200-PE6 BK - 18 XN-C6 Component Locations Table)
1552272
K X800-XA14 OR- 18 J764-XA15 BR- 18 XA-C2 3463506 138-1234 Part Number
L J764-XA15 BR - 18 1552269 A 123-XN5 WH - 0.75
STOP 1 604-RV17 OR - 18
M J984-XA17 PK - 18 J832-XA28 YL- 18 902-XA5 BR- 18 1
(146) SPEED CLUTCH 3 SOL CONN 37 B 200-XN6 BK - 1.00
STOP TAIL TURN LED LAMP LH TURN 2 605-RV5 YL - 18 280-7009 CONNECTS TO HL-C1
GND 3 PE-C5 975-XA6 WH- 18 2 C 115-XN8 RD- 1.00 XN-C8
387-6627 200-RV15 BK - 18 (ET SOL 6) LOCATED AT D-1
TAIL 1552269 J879-XA27 GN- 18 J879-XA25 GN- 18 D 161-XN9 RD- 1.00 115-XN8 RD - 1.00 115-XN8 RD - 1.00 3463496
4 617-RV19 BR - 18
G (94) SIDE SHIFT RIGHT SOL
238-4626
1
2
M721-PE22 WH- 18
200-PE7 BK- 18 200-PE6 BK- 18 200-PE5 BK- 18
(135) PUMP DISCHARGE PRESS SNSR (AUTO) XA-C9
344-7391 2304013
J879-XA8 GN- 18
J879-XA16 GN- 18
123-XN5 WH - 0.75 123-XN5 WH - 0.75 123-XN5 WH - 0.75
200-XN7 BK - 1.00
A
B CONN 38
CONNECTS TO HM-C1
G
161-XN3 RD - 1.00 161-XN10 RD - 1.00 115-XN8 RD - 1.00 C
200-PE8 BK- 18 +(POS) V 1 J984-XA17 PK- 18 161-XN9 RD - 1.00 161-XN10 RD - 1.00 D LOCATED AT J-5
RV-C3 X800-XA14 OR- 18
200-RV13 BK - 18 200-PE15 BK- 18 GROUND 2 XA-C4 (148) FACE FAN 2 LH BEACON SOCKET
1552269 J764-XA15 BR - 18 XN-C2
200-RV14 BK - 18 200-PE7 BK- 18 SIGNAL 1552269 106-1744 200-XN4 BK - 1.00 200-XN7 BK - 1.00 RP-C10 9R-7941
PE-C4 3 J984-XA17 PK - 18 M739-XA11 YL- 18 2458026
(61) REAR HORN 1 367-RV6 BU - 18 200-RV15 BK - 18 200-RV1 BK - 18 200-PE10 BK- 18 (139) FWD HIGH SOL 200-XN6 BK - 1.00 1237615
1552269 X800-XA14 OR- 18 900-XA7 PU- 18 1 BK-18 1 1
164-9425 2 200-RV14 BK - 18 200-RV16 BK - 18 200-PE23 BK- 18 280-7009 200-XN4 BK - 1.00 603-RP16 PK- 18 LH BEACON ROTATING
1 J879-XA8 GN - 18 2 PK-18 2 161-XN3 RD- 1.00 200-RP3 BK- 18 309-1325
(106) SIDE SHIFT RIGHT SUPPR M721-PE21 WH- 18 (ET SOL 2) 2
189-3158 2 200-PE8 BK- 18 M719-PE17 GN- 18 PE-C1 B
321-RV2 BR - 18 (136) XMSN OUT SPEED SNSR (AUTO) XA-C12
RV-C1 RT-C12 M719-PE18 GN- 18 M719-PE16 GN- 18 3E3370 L LH BEACON STROBE ATCH
367-RV6 BU - 18 191-8304 1552269
RV-C6 3463512 3463502 M719-PE27 GN- 18 200-PE5 BK- 18 A CONN 3 SIG -(NEG) 1 E901-XA19 GN- 18
H 140-3668
1552269 M719-PE16 GN- 18 B
200-RV1 BK - 18 A 200-RT46 BK- 0.75 CONNECTS TO PL-C18 SIG +(POS) 2 E900-XA20 WH- 18 M
(53) BACKUP ALARM RD-16 1 321-RV2 BR - 18 PE-C10 M720-PE13 BU- 18 M721-PE20 WH- 18 C VOL 1 LOC H-16 XA-C5
604-RV17 OR- 18 604-RV7 OR- 18 321-RV2 BR - 18 B 321-RT22 BR- 0.75
154-5428 BK-16 2 E747-RV11 BK - 18 1552269 M720-PE14 BU- 18 1552269
604-RV18 OR- 18 618-RV3 YL - 18 C 618-RT7 YL - 0.75
(87) LOCKOUT SOL 1 M720-PE13 BU- 18 M720-PE24 BU- 18 (143) REV SOL AS AUTO 200-RP13 BK- 12
606-RV4 GY- 18 D 606-RT9 GY- 0.75 754-XA12 BU- 18 1
238-4628 2 200-PE23 BK- 18 M720-PE26 BU- 18 280-7009 200-RP7 BK- 12
605-RV5 YL - 18 605-RV5 YL - 18 E 605-RT3 YL - 0.75 F761-XA23 BR- 18 2
RV-C4 (ET SOL 3)
606-RV4 GY- 18 367-RV6 BU - 18 F 367-RT5 BU- 0.75
1552272 604-RV7 OR- 18 G 604-RT13 OR- 0.75 M721-PE21 WH- 18 FACE FAN (ATCH)
STOP 1 604-RV18 OR- 18 M721-PE22 WH- 18 M721-PE20 WH- 18 (59) GND CAB RF
617-RV19 BR - 18 617-RV9 BR - 18 X800-RV8 OR- 18 H X800-RT42 OR- 0.75
STOP TAIL TURN LED LAMP RH TURN 2 606-RV4 GY- 18 PE-C7 M721-PE25 WH- 18
617-RV20 BR - 18 617-RV9 BR - 18 J 617-RT12 BR- 0.75
387-6627 GND 3 200-RV16 BK - 18 1552269
627-RV10 YL - 18 K 627-RT28 YL - 0.75
TAIL 4 618-RV3 YL - 18 (99) LOCKOUT SOL SUPPRESSOR 1 M720-PE14 BU- 18 XA-C13 NOTE A
618-RV3 YL - 18 E747-RV11 BK - 18 L E747-RT17 BK- 0.75 200-RP1 BK- 18
627-RV10 YL - 18 T907-RV24 GN- 18 M T907-RT41 GN- 0.75 189-3158 2 200-PE15 BK- 18 1552269 200-RP2 BK- 18
(140) FWD LOW SOL AUTO RP-C7
E747-RV11 BK - 18 J764-RV27 BR - 18 N J764-RT14 BR- 0.75 752-XA9 YL - 18 1 200-RP3 BK- 18
280-7009 1552269
P H801-XA24 PU- 18 2 200-RP4 BK- 18
(ET SOL 1) 620-RP25 WH- 18 1 FRONT LH LONG BEAM ATCH
RV-C7 J764-RV21 BR - 18 J764-RV27 BR- 18 CONN 29 PE-C8
200-RP5 BK- 18
200-RP2 BK- 18 2 214-2969
1552267 J764-RV22 BR - 18 200-RP6 BK- 18
1552269 RP-C3 200-RP8 BK- 18 200-RP7 BK- 12
A X800-RV25 OR- 18 T907-RV12 GN- 18 T907-RV24 GN- 18 (57) SIDE SHIFT DIODE #1 1 M720-PE24 BU- 18 1552269
(74) CONNECTS TO RH STAB LEG SENSOR B J764-RV22 BR - 18 189-3158 2 XA-C15 RP-C6
T907-RV26 GN- 18 M721-PE25 WH- 18 REAR LH LONG BEAM ATCH 1 630-RP28 GY- 18
387-6626 C T907-RV12 GN- 18 2304011 1552269
214-2969 2 200-RP9 BK - 18
X800-RV23 OR- 18 X800-RV8 OR- 18 452-XA18 PU- 18 1 (134) CONVERTER TEMP SENSOR AUTO 200-RP9 BK- 18 607-RP19 PK- 18 1 FRONT LH WIDE FLOOD STD
X800-RV25 OR- 18 202-XA30 BK- 18 2 425-1817 200-RP10 BK - 18 200-RP1 BK- 18 2 214-2968
F PE-C11
1552269 T RP-C2
1552269
200-RP11 BK - 18
200-RP12 BK - 18
F
(58) SIDE SHIFT DIODE #2 1 M720-PE26 BU - 18 RP-C9
REAR LH WIDE FLOOD STD 1 608-RP22 GN- 18
189-3158 2 M719-PE27 GN- 18 1552269
214-2968 2 200-RP10 BK - 18 200-RP13 BK- 12
200-RP14 BK- 14 607-RP20 PK- 18 1 FRONT RH WIDE FLOOD STD
200-RP15 BK- 14 200-RP5 BK- 18 2 214-2968
POWERED SIDESHIFT (SS ONLY) - ATCH AUTOSHIFT XMSN SOL - ATCH RP-C4
1552269 603-RP16 PK- 18 RP-C8
REAR RH WIDE FLOOD STD 1 608-RP23 GN- 18 603-RP17 PK- 18 1552269
214-2968 2 200-RP11 BK - 18 603-RP18 PK- 16
620-RP26 WH- 18 1 FRONT RH LONG BEAM ATCH
LF-C3 LF-C1 RV-C5 2
607-RP19 PK- 18 200-RP6 BK- 18 2142969
2304011 3E3370 1552267
RP-C5 607-RP20 PK- 18
1 627-LF5 YL - 18 627-LF5 YL - 18 A 627-RV10 YL - 18 1552269
2 B 607-RP21 PK- 16 RP-C1
200-LF2 BK - 18 617-RV20 BR- 18
REAR RH LONG BEAM ATCH 1 630-RP29 GY- 18
200-LF1 BK - 18 C 200-RV13 BK- 18 1552252
(120) STABILITY PRESSURE SW 214-2969 2 200-RP12 BK - 18 608-RP22 GN- 18 608-RP24 GN- 16
REAR FOG LAMP 1
262-4727 CONN 26 614-TA2 PU- 18 F444-TA7 PU - 16 TC-C2 TF-C1 TF-C2 SEE TABLE 608-RP23 GN- 18
2
2304013 2304014 1552272
8 1 3 4 6 10 620-RP25 WH- 18 3
(121) STABILITY WARNING SW 200-TC1 BK- 16 200-TC3 BK- 18 1 200-TF2 BK- 18 1 GND
387-6577 TA-C3 TC-C1 620-RP26 WH- 18 4
LF-C2 200-TC2 BK- 16 F444-TC7 PU - 18 2 F444-TF1 PU- 18 2 +(POS) 12V CONN 136
TA-C2 2304013 2304014 620-RP27 WH- 16 5
1552269 131-TA1 BR- 16 E479-TC4 YL - 18 3 E479-TF3 YL - 18 3 OUT (SWB)
2305009 200-RP15 BK- 14 6 CONNECTS TO HL-C8
1 200-TA6 BK- 16 1 200-TC1 BK- 16 F444-TC5 PU- 16 4
617-LF4 BR - 18 617-LF4 BR - 18 1 131-TA1 BR- 16 200-TA5 BK- 18 CONN 35 630-RP28 GY- 18 200-RP14 BK- 14 7 VOL 2 LOC C-3
2 200-LF3 BK - 18 CONN 24 2 614-TA2 PU- 18
TA-C1 F444-TA7 PU- 16 2 F444-TC6 PU- 16 F444-TC6 PU- 16
630-RP29 GY- 18 630-RP30 GY- 16 603-RP18 PK- 16 8
200-TA4 BK- 16 200-TA6 BK- 16 7 2 5 9 1429117 E479-TA3 YL - 18 3 E479-TC4 YL - 18
CONNECTS TO RH-C18 3 E479-TA3 YL - 18 620-RP27 WH- 16 9
LICENCE PLATE LAMP VOL 3 LOC B-10 607-RP21 PK- 16 10
196-0030
4 200-TA4 BK- 16 614-TA2 PU- 18 200-TA5 BK- 18 CONN 33 E479-TC4 YL - 18 11
E479-TA3 YL - 18 131-TA1 BR- 16 630-RP30 GY- 16
200-TC2 BK- 16 12
STABILITY PRESSURE SWITCH 608-RP24 GN- 16
200-TA6 BK- 16 200-TA6 BK- 16 F444-TC5 PU- 16 TC-C3 PART COLOUR PRESS.
E479-TA3 YL - 18 E479-TA3 YL - 18 1552269 RH BEACON SOCKET
387-9170 BU 110 BAR RP-C11 9R-7941
F444-TC5 PU- 16 1
1237615
200-TC2 BK- 16 2 NOT CONNECTED 387-9171 GR 135 BAR 1
387-9172 YL 144 BAR 603-RP17 PK- 18 RH BEACON ROTATING
200-RP4 BK- 18 309-1325
E 387-9173 RD 155 BAR 2
E
387-9174 BR 170 BAR
REAR FOG & LICENCE PLATE
REAR FRAME (SS ONLY) OBJECT HANDLING (STABILITY WARNING) (SS ONLY) - ATCH CAB ROOF (SS ONLY)
LAMPS (ATCH) (SS ONLY)
PA-C4 (55) PRODUCT LINK 631 SAT

WP-C1 4518019 (63) REAR WIPER MOTOR AS (63) REAR WIPER MOTOR AS
3463509 442-7199
382-2200 382-2370
WP-C7 WA-C1 A
A 136-WP12 GN- 16 1552253 1907612 PROD LINK ANTENNA CP ONLY SS ONLY
B BATT +
B A907-WP28 BU- 16 443-8463 12uH 0.47uF 15uH 0.47uF
136-WP10 GN- 16 1 136-WA1 GN- 16 (124) AWS VALVE F711-PA11 YL - 0.75 C BATT -
CONN 14 C R908-WP33 YL - 16
985-WP2 GY- 18 2 985-WA2 GY- 16 373-6998 F712-PA14 GN - 0.75 D
CONNECTS TO PL-C38
KEYSWITCH
MOTOR MOTOR
CONNECTS TO PL-C54 D 202-WP18 BK- 16 WA-C2 VOL 1 LOC F-5
986-WP3 OR- 18 3 986-WA3 OR- 18 E OR BACKUP BATTERY TIMER MODULE
VOL 1 LOC B-9 E F711-WP1 YL - 18 1552269 A F ETHERNET TX+
F F712-WP32 GN- 18
C851-WP4 YL - 18 4 C851-WA4 YL - 18
H758-WA5 BR- 18 1 RD-18 2 WHEEL G
CONN 34 TO PRODUCT LINK JUMPER
ETHERNET TX-
H758-WP5 BR- 18 5 H758-WA5 BR - 18 CONNECTS TO PA-C2
G 453-WP34 PK- 18 H767-WA8 BR- 18 H767-WA13 BR- 18 2 BR-18 STEER H TO SERVICE CONNECTOR ETHERNET RX+
H759-WP6 OR- 18 6 H759-WA6 OR- 18 125-PA1 RD- 0.75 VOL 2 LOC AT D-6
H PA-C1 J ETHERNET RX-
H764-WP7 GY- 18 7 H764-WA7 GY- 18 202-PA2 BK- 0.75 OR
H767-WP8 BR- 18 8 H767-WA8 BR- 18 2698229 308-PA3 YL - 0.75 K TO PRODUCT LINK BLUETOOTH DTR (CELL WAKEUP)
WA-C3 1513-PA8 BU - 0.75 L ETHERNET SHIELD
H768-WP9 BR- 18 9 H768-WA9 BR- 18 1 125-PA1 RD- 0.75 CONNECTS TO PH-C2
1552269 B M CAN HIGH
417-WP22 GY- 18 10 2 202-PA2 BK - 0.75 1510-PA9 YL - 0.75 1512-PA7 WH - 0.75 VOL 3 LOC I-6
202-WP21 BK- 16 11 986-WA3 OR- 18 1 RD-18 4 WHEEL CONN 21 3 308-PA3 YL - 0.75 1511-PA10 OR - 0.75 N CAN LOW PRODUCT LINK CABLE
G795-WP27 OR- 16 H767-WA14 BR- 18 2 BR-18 STEER HL-C3
985-WP2 GY- 18 202-WP21 BK- 16 12 202-WA12 BK- 16 4 1510-PA9 YL - 0.75 P ANT 1 379-2153
RD
WH
CONNECTS TO PL-C38
BR
GN
GN
BK
RD
RD
1511-PA10 OR- 0.75
YL
BK
A884-WP29 WH- 16 202-WP21 BK- 16 MOTOR AS 1762946 MOTOR AS
R908-WP33 YL - 16 986-WP3 OR- 18 VOL 1 LOC F-5 5 446-6267 RD 1 119-HL30 PK- 2.00 446-6270 RD 1
C851-WP4 YL - 18 CONN 52 6 1512-PA7 WH- 0.75 ANT 2
BK 2 200-HL1 BK- 2.00 BK 2
WA-C5 SWG 1
8 1 3 4 6 10 H758-WP5 BR- 18 7
1552269 CONN 121 WH 3 507-HL27 WH- 0.75 WH 3
SPEED 1
SPEED 1
AWS SW H759-WP6 OR- 18 C 8 PA-C2 SWG 2
CONNECTS TO PH-C2 1513-PA8 BU- 0.75 OR 4 614-HL18 PU- 0.75 OR 4
WASH
(108) AWS MODE SW H764-WP7 GY- 18 985-WA2 GY- 16 1 RD-18 CRAB 9 3313578
FUNCTION CONNECTIONS
OFF
OFF
387-6538 H768-WA9 BR- 18 H768-WA15 BR- 18 2 BR-18 STEER VOL 3 LOC I-6 10 11 3 12 6 8 1 3 6
INT
H767-WP8 BR- 18 10 125-PA1 RD- 0.75 1 NOT CONNECTED SWG WAKEUP
MOM
2WS 2&1 5&4
MOM
H768-WP9 BR- 18 11 F711-PA6 YL - 0.75 202-PA2 BK - 0.75 2 R-TERM
4WS 2&3 5&6 WP-C3 F711-PA6 YL - 0.75 F711-PA4 YL - 0.75 3
136-WP11 GN - 16 12 F712-PA5 GN- 0.75 308-PA3 YL - 0.75
7 2 5 9 2285856 (54) AWS CONTROL WA-C4 F711-PA11 YL - 0.75 4
202-WP15 BK - 18 136-WP10 GN- 16 WP-C5 1552269
436-9796 D 1510-PA9 YL - 0.75 5 TO PRODUCT LINK SWG 3 WASH SW
A907-WP28 BU - 16 202-WP16 BK - 18 (GREY CONNECTOR) 2538110
D 136-WP11 GN - 16
202-WP15 BK - 18
202-WP17
417-WP22
BK - 18
GY- 18
C450-WP24 YL - 18 1 CRAB LED
H759-WA6 OR- 18
H768-WA16 BR - 18
1
2
RD-18
BR-18
CIRCLE
STEER
F712-PA5 GN- 0.75 F712-PA13
F712-PA14
GN- 0.75
GN- 0.75
1511-PA10 OR - 0.75
1512-PA7 WH - 0.75
6
7
(PL-631 OR PL641)
12-PIN CONNECTOR
9 13 14 15 16 446-6266 7 2 5 D
985-WP23 GY- 16
2 NOT USED 1513-PA8 BU - 0.75 8 LOCATED AT E-5/D-5 REAR WIPER SW CONN 37
136-WP14 GN- 16 H758-WP5 BR- 18 3 2WS SOLENOID +(POS) REAR WIPER SW HL-C1
9 PRODUCT LINK 631 387-6548 CONNECTS TO XF-C6
C450-WP24 YL - 18 136-WP12 GN- 16 H767-WP8 BR- 18 4 2/4WS SOLENOID RETURN 387-6619 3463496
A884-WP29 WH - 16 10 VOL 2 LOC H-5
U763-WP31 BU - 16
985-WP23 GY- 16
136-WP13 GN- 16 985-WP2 GY- 18 5 CRAB SOLENOID +(POS) F711-PA4 YL - 0.75 11 SATELLITE - ATCH 123-HL100 WH - 0.75 A
OR
136-WP11 GN- 16 202-WP20 BK- 16 6 BATTERY -(NEG) VE F712-PA13 GN - 0.75 12 115-HL33 RD- 1.00 200-HL32 BK - 1.00 B
C451-WP25 YL - 18 A907-WP28 BU - 16 CONNECTS TO XN-C6
136-WP14 GN- 16 7 BATTERY +(POS) VE 115-HL33 RD- 1.00 C
C450-WP24 YL - 18 VOL 2 LOC G-5
202-WP15 BK- 18 H759-WP6 OR- 18 8 CIRCLE SOLENOID +(POS) 119-HL30 PK - 2.00 161-HL28 RD- 1.00 D
8 1 3 4 6 10 C451-WP25 YL - 18
202-WP16 BK- 18 202-WP20 BK- 16 H768-WP9 BR- 18 9 CIRC/CRAB SOL RETURN (149) PRODUCT LINK 641 CELL 123-HL100 WH- 0.75 OR
CRAB / CIRCLE SW G795-WP27 OR - 16 10 4WS SOLENOID +(POS) PRODUCT LINK 631/641 JUMPER
202-WP17 BK- 18 202-WP21 BK- 16 986-WP3 OR- 18 440-2104 CONN 40
(112) CRAB CIRCLE SW R908-WP33 YL - 16
FUNCTION CONNECTIONS 202-WP18 BK- 16 417-WP22 GY- 18 11 2WS LED (REQUIRED FOR FLASHING SOFTWARE ONLY) 161-HL28 RD- 1.00
387-6537 U763-WP31 BU - 16 BATT + CONNECTS TO HM-C1
CIRCLE 2&1 5&4 202-WP19 BK- 16 C451-WP25 YL - 18 12 CIRCLE LED
WP-C4 CONNECTS TO PL-C38 BATT - HL-C4 VOL 2 LOC F-5
CRAB 2&3 5&6 7 2 5 9 2285856 417-WP22 GY- 18 VOL 1 LOC F-5 KEYSWITCH 3463513
200-HL1 BK - 2.00
453-WP34 PK- 18 WP-C6 131-HA1 BR- 16 131-HA5 BR- 16 BACKUP BATTERY A
200-HL3 BK - 2.00 200-HL32 BK - 1.00 603-HL8 PK - 1.00
985-WP23 GY- 16 (BLACK CONNECTOR) 2538111 HA-C1 131-HA6 BR- 16 TO PRODUCT LINK JUMPER ETHERNET TX+ B
HL-C8 200-HL5 BK - 2.00 620-HL19 WH - 1.00
202-WP17 BK - 18 A907-WP28 BU- 16 453-WP34 PK- 18 1 4WS FAULT (SWG) 2305009 CONNECTS TO PA-C2 ETHERNET TX- 608-HL2 GN - 1.00 C
A884-WP29 WH- 16 2 CAN LO 200-HA4 BK- 16 200-HA8 BK- 16 VOL 2 LOC AT D-6 ETHERNET RX+ 3313599
F712-WP32 GN- 18 1 131-HA1 BR- 16 507-HL27 WH- 0.75 607-HL4 PK - 1.00 D
202-WP16 BK - 18 C450-WP24 YL - 18 F711-WP1 YL- 18 3 CAN HI CONN 24 2 614-HA2 PU- 18
200-HA7 BK- 16 ETHERNET RX- 1 605-HL29 YL - 0.75 603-HL8 PK - 1.00 614-HL18 PU - 0.75 E
C451-WP25 YL - 18 G795-WP27 OR- 16 4 2WS INPUT (69) REAR AXLE POSITION SENSOR CONNECTS TO RH-C18 3 E479-HA3 YL - 18 TO PRODUCT LINK BLUETOOTH DTR (CELL WAKEUP) 2 606-HL23 GY- 0.75 630-HL17 GY- 1.00 F
C853-WP26 GN- 18 H764-WP7 GY- 18 5 REAR AXLE SENSOR N/O
WA-C6 395-3476 VOL 3 LOC B-10 4 200-HA4 BK- 16
614-HA2 PU- 18 CONNECTS TO PH-C2 ETHERNET SHIELD CONN 36 3 604-HL16 OR- 0.75
604-HL16 OR- 0.75
G CONN 6
1552272 605-HL29 YL - 0.75 604-HL16 OR - 0.75
F711-WP1 YL- 18 H765-WP30 WH- 18 6 FRONT AXLE SENSOR N/O E479-HA3 YL - 18 VOL 3 LOC I-6 CAN HIGH TO CAB ROOF HARN (CP ONLY) 4 618-HL20 YL - 0.75 H CONNECTS TO PL-C49
606-HL23 GY- 0.75 605-HL29 YL - 0.75
F712-WP32 GN- 18 C853-WP26 GN- 18 7 FRONT AXLE SENSOR N/C 202-WA12 BK- 16 1 BK GND CAN LOW CONNECTS TO RF-C1 5 617-HL21 BR - 0.75 J VOL 1 LOC E-16
HC-C3 (116) HBCV DETENT SW 607-HL4 PK - 1.00 606-HL23 GY- 0.75
G795-WP27 OR- 16 C851-WP4 YL- 18 8 REAR AXLE SENSOR N/C C851-WA4 YL - 18 2 BK PROXIMITY N/C VOL 3 LOC H-2 6 200-HL3 BK - 2.00
1552267 449-1587 608-HL2 GN - 1.00 617-HL21 BR - 0.75 K
H764-WA7 GY- 18 3 BK PROXIMITY N/O 7 200-HL5 BK - 2.00
H765-WP30 WH- 18 U763-WP31 BU- 16 9 CIRCLE INPUT
136-WA1 GN- 16 4 BK +(POS) 12V 131-HC1 BR- 16 A BK CONN 136 8 603-HL8 PK - 1.00
614-HL18 PU - 0.75 618-HL20 YL - 0.75 L
R908-WP33 YL - 16 985-WP23 GY- 16 10 CRAB INPUT TO CAB ROOF HARN (SS ONLY) 617-HL21 BR - 0.75 161-HL28 RD- 1.00 M
(68) FRONT AXLE POSITION SNSR HA-C2 HC-C1 B BR SWG 1 9 620-HL19 WH - 1.00
11 CAN SHIELD CONNECTS TO RP-C1 618-HL20 YL - 0.75 119-HL30 PK - 2.00 N
395-3476 WE-C2 WE-C1 WP-C2 1552269 3E3364 E997-HC5 BR- 16 C BU SWG 2 10 607-HL4 PK - 1.00
U763-WP31 BU- 16 12 NOT USED VOL 2 LOC E-1 620-HL19 WH- 1.00 507-HL27 WH - 0.75 P
1552272 3E3376 1552272 131-HA5 BR- 16 1 131-HC1 BR- 16 11 630-HL17 GY- 1.00 630-HL17 GY- 1.00 123-HL100 WH - 0.75 R
GND BK 1 200-WE4 BK - 18 1 202-WP19 BK - 16 200-HA8 BK- 16 2 200-HC2 BK- 16 NOT CONNECTED SWG WAKEUP 12 608-HL2 GN - 1.00 115-HL33 RD- 1.00 S
PROXIMITY N/C BK 2 C853-WE3 GN- 18 2 C853-WP26 GN- 18 HBCV HOSE VALVE AS. R-TERM
PROXIMITY N/O BK 3 H765-WE2 WH - 18 3 H765-WP30 WH - 18
CONN 32
HA-C3 421-5427 INTERNAL ROOF
+(POS) 12V BK 4 143-WE1 BR - 16 4 136-WP13 GN- 16
C CONN 25 131-HA6 BR - 16
2305008
1 CONN 24 HC-C2
SWG 3
VOLUME 2 C
614-HA2 PU - 18 2 1552269
CONNECTS TO TA-C2
E479-HA3 YL - 18 3
VOL 3 LOC E-12
E997-HC5 BR- 16 1 (77) HBCV SOL IDENT PART NO. CHG DESCRIPTION NOTE
200-HA7 BK - 16 4 200-HC2 BK- 16 2 274-8041
PRODUCT LINK 641
AC 387-6636 02 HVAC - CONSOLE J
AWS FRONT AXLE (EST ONLY) - ATCH AWS PLATFORM (EST ONLY) - ATCH AWS REAR AXLE (EST ONLY) - ATCH HOSE BURST CHECK VALVE (HBCV) - ATCH
CELL - ATCH AT 387-6572 01 IMMOBILISER J
FL 387-6614 03 FRONT ROADING LIGHT - LEFT
(65) ANTITHEFT RELAY 1
614-AC15 PU - 18
AT-C2 115-1615
FR 387-6532 03 FRONT ROADING LIGHT - RIGHT
9X1054
779-KP45 WH - 18
779-KP10 WH - 18
585-KP4 YL - 18
RK-C5 E528-AC13 PU - 14
E528-AC12 PU - 14 AT-C1 314-AT8 PU- 12 1
30 HA 432-2438 01 HOSE BURST CHECK VALVE (CAB) H,J
1552269 86
5
586-KP7 BR - 18
N939-RK9 GN- 18 1 (103) RIDE CONTROL ARC SUPPRESSOR
522-AC20 WH- 18
614-AC23 PU - 18
3463510 308-AT10 YL - 18
743-AT9 PU- 18 2
HC 430-7914 02 HOSE BURST CHECK VALVE (REAR) H,J
2 189-3158 A 85
200-RK10 BK- 18 4
8 1 3 4 6 10 8 1 3 4 6 10
B 308-AT10 YL - 18
304-AT12 WH- 12
3
87 HL 452-7862 01 INTERNAL ROOF
C 314-AT8 PU- 12 87a
MOM
MOM
CONN 17 D 202-AT2 BK- 18 HM 450-3826 01 HEADLINER

(118) LOADER QC PINS SW (117) HEATER A/C SW CONNECTS TO PL-C45 E X977-AT3 YL - 12
387-6589 387-6542 VOL 1 LOC B-5 F X977-AT4 YL - 12
(66) ANTITHEFT RELAY 2
HR 387-6696 00 RADIO J
KP-C1 NOTE M AC-C3 G K906-AT1 GN - 18 AT-C3
7 2 5 9 1429117 RK-C4
1552269
7 2 5 9 1429117 (123) VENT SW H 304-AT12 WH- 12 9X1054
115-1615 KL 387-6663 01 QUICK COUPLER - LOADER J
KP-C6 (100) QC ARC SUPPRESSOR #3 387-6543 J 743-AT9 PU- 18 30
202-KP40 BK - 18 143-KP42 BR - 18 1552269 189-3158 200-RK3 BK- 18 N939-RK7 GN- 18 1 RD-18 (92) RIDE CONTROL SOL #2 200-AC22 BK - 18 NOTE M K X977-AT3 YL - 12
K906-AT1 GN - 18
1
5
86 KP 387-6664 01 QUICK COUPLER - PLATFORM J
1 200-RK1 BK- 18 200-RK8 BK- 18 200-RK8 BK- 18 2 RD-18 238-4628 124-AC5 GN- 18
143-KP43 BR - 18 143-KP1 BR- 18 779-KP17 WH- 18
143-KP43 BR - 18
143-KP44 BR - 18 200-KP21 BK- 18 2
RK-C1
3E3382
200-RK10 BK- 18 HEATER / AC SW 122-AC1 BU - 12 202-AT2 BK- 18
X977-AT4 YL - 12
2
4
85 KT 211-9461 04 QUICK COUPLER - BROOM J
200-AC8 BK - 18 87
FUNCTION CONNECTIONS
200-KP16 BK- 18 1 J764-RK2 BR- 18 976-RK4 OR- 18 976-RK4 OR- 18
HEATER ON 2&3 5&6
3 87a LF 327-4172 03 REAR FOG LAMP & LICENCE PLATE LAMP J
200-KP21 BK- 18 CONN 10 2 200-RK1 BK- 18 J764-RK2 BR- 18 J764-RK2 BR- 18
614-KP36 PU - 18
578-KP3 BU - 18 200-KP24 BK- 18 KP-C7 (101) QC ARC SUPPRESSOR #4 CONNECTS TO PL-C40
3 N939-RK5 GN - 18 AC ON 2&1 5&4 LN 415-5744 01 LOAD CHECK DISABLE J,K
200-KP25 BK- 18 1552269 189-3158 4 976-RK4 OR- 18 N939-RK5 GN- 18 N939-RK6 GN- 18 RK-C2
VOL 1 LOC C-11 SECURITY
5 1552269 122-AC1 BU- 12 122-AC1 BU- 12 PA 455-0946 02 PRODUCT LINK PL631 / PL641
B 8 1 3 4 6 10
200-KP26 BK- 18 L998-KP27 OR - 18
200-KP24 BK- 18
1
2 6
X800-RK11 OR- 18 N939-RK7 GN- 18
N939-RK9 GN- 18 N939-RK6 GN- 18 1 RD-18 (91) RIDE CONTROL SOL #1
124-AC5 GN- 18 124-AC5 GN- 18 B
202-KP38 BK- 18 200-RK3 BK- 18 2 RD-18 238-4628
614-AC14 PU - 18
517-AC19 BU - 14 200-AC10 BK- 12
PE 357-3252 02 POWERED SIDE SHIFT J
202-KP39 BK- 18 202-KP2 BK- 18 X800-RK11 OR- 18 X800-RK11 OR- 18
(114) EXTERNAL POWER SW
387-6588 202-KP40 BK- 18
516-AC18 GN- 14
515-AC4 GY- 18
200-AC8 BK- 18
200-AC9 BK- 18 200-AC2 BK- 12 AC-C7
PV 387-6686 02 RETURN TO DIG JUMPER (PLATFORM) (420F2 ST & G,J
202-KP41 BK- 18 KP-C8 (102) QC ARC SUPPRESSOR #5 3463510
KP-C9 1552269 189-3158
E529-AC21 YL- 14 E528-AC26 PU- 14 200-AC22 BK- 18
200-AC25 BK- 14
200-AC27 BK- 12
A
PX 387-6690 01 RETURN TO DIG (LOADER) (SINGLE TILT) G,J
7 2 5 9 1429117 122-AC1 BU- 12
578-KP3 BU- 18 578-KP3 BU- 18 L999-KP29 GN - 18 1 8 1 3 4 6 10
585-KP4 YL - 18 585-KP4 YL - 18 200-KP25 BK- 18 2 RK-C3 (72) RIDE CONTROL SENSOR 515-AC4 GY- 18 515-AC4 GY- 18
614-AC6 PU- 18 B
C
FL-C1 FL-C2 RK 331-5471 02 RIDE CONTROL J
C568-AC24 WH- 12 3463507 1552273
586-KP7 BR- 18 586-KP7 BR- 18 2304013 344-7391 TURN
143-KP44 BR - 18 (109) BLOWER SPEED SW 516-AC18 GN- 14 519-AC7 PK- 18 D CONN 7 A 611-FL3 PU - 16 605-FL2 YL - 18 1 BU RP 415-5733 02 ROOF (SS ONLY)
202-KP39 BK - 18 X800-RK11 OR- 18 1 RD-18 +5 VOLTS 387-6544 C568-AC3 WH- 12 E CONN 13 B 2 BK
614-KP35 PU- 18 CONNECTS TO PL-C35 200-FL1 BK - 14 200-FL1 BK- 14 POSN
614-KP35 PU - 18 614-KP36 PU- 18 614-KP23 PU- 18
J764-RK2 BR- 18
976-RK4 OR- 18
2
3
YL-18 GROUND
GN-18 SIGNAL
AC-C2
1429117
517-AC19 BU- 14 F
G
VOL 1 LOC D-16 CONNECTS TO PL-C29 C 619-FL4 GN - 16 617-FL5 BR- 18 3 BR RT 452-0236 01 REAR END VALVE BLOCK (SS ONLY)
7 2 5 9 515-AC4 GY- 18 VOL 1 LOC J-11 D 617-FL5 BR - 18 611-FL3 PU- 16 4 RD
P993-KP34 OR- 18 614-KP37 PU- 18
852-KP11 GN- 18 E529-AC21 YL - 14 200-AC25 BK- 14
519-AC7 PK- 18
522-AC20 WH- 18
519-AC7 PK- 18 200-AC2 BK- 12 H E 605-FL2 YL - 18 5
HIGH
LOW RV 387-6618 05 REAR FRAME (SS ONLY)
124-AC5 GN - 18 J 619-FL4 GN- 16 6 GN
779-KP33 WH- 18 KP-C2
779-KP17 WH- 18 3E5179
E528-AC11 PU- 14
200-AC9 BK- 18
200-AC27 BK- 12 K TA 387-6701 02 OBJECT HANDLING - SIDE J
8 1 3 4 6 10 (111) CONTINUOUS FLOW SW 779-KP18 WH- 18 143-KP1 BR- 18 1 RIDE CONTROL - ATCH 614-AC14 PU - 18 LH HEADLIGHT AS TC 357-3234 02 OBJECT HANDLING - REAR J
MOM
387-6528 779-KP10 WH- 18 202-KP2 BK- 18 2 614-AC15 PU - 18 614-AC6 PU- 18

AC-C6 RH DIP 195-0190
852-KP11 GN- 18 852-KP11 GN- 18
200-KP16 BK- 18
852-KP11 GN - 18
3
4 2861754
614-AC23 PU - 18 LH DIP 195-0192 TF 349-1100 03 OBJECT HANDLING - HOE J
J878-KP13 YL - 18 J878-KP13 YL - 18 CONN 12
7 2 5 9
KP-C4
1429117
P993-KP34 OR- 18
J878-KP13 YL - 18
5
6 CONNECTS TO PL-C58 (62) BLOWER MOTOR MOTOR
A
B
C568-AC16 WH- 12
200-AC10 BK - 12
C568-AC16 WH- 12
C568-AC17 WH- 12
C568-AC3 WH- 12
C568-AC24 WH- 12
WA 357-3243 02 AWS - REAR AXLE (EST ONLY)
143-KP42 BR - 18 417-8129 ROADING LIGHT - LEFT (SS ONLY)
202-KP38 BK - 18 L998-KP14 OR- 18 L998-KP28 OR- 18
614-KP23 PU- 18
585-KP4 YL - 18
7
8
VOL 1 LOC F-11
200-KL5 BK- 18 E528-AC11 PU- 14
WE 357-9536 03 AWS - FRONT AXLE (EST ONLY)
202-KP41 BK - 18 L998-KP27 OR- 18
J878-KP13 YL - 18
202-KP41 BK - 18 614-KP35 PU - 18
586-KP7 BR- 18
779-KP33 WH- 18
9
10
200-KL14 BK- 18
200-KL15 BK- 18
E528-AC12
E528-AC13
PU- 14
PU- 14
WP 387-6679 03 AWS - CAB (EST ONLY)
614-KP37 PU - 18 L999-KP29 GN- 18 KT-C3
852-KP11 GN- 18 L999-KP15 GN- 18 L999-KP30 GN- 18
11
12
1561460 E528-AC26 PU- 14 XA 387-6551 01 XMSN - AUTOSHIFT G
A AC-C4
200-KT2 BK- 16 200-KT6 BK- 14 200-KT6 BK- 14
614-KP46 PU - 18 J878-KP13 YL - 18 P993-KP34 OR- 18 P993-KP34 OR- 18 200-KT7 BK- 14 578-KT1 BU- 14 B 3E3364 XF 450-3827 02 DOOR SWITCH G,J
KP-C3 KL-C1 THERMOSTAT WIRE AS 1 522-AC20 WH- 18
L998-KP14 OR - 18 KL-C3 KT-C1 200-KT8 BK- 14 L999-KT13 GN- 14 C
614-KP37 PU- 18
L999-KP15 GN - 18
1552264 3E3388
3E3382 1552273 200-KT9 BK- 16 L998-KT10 OR- 14 D 384-7497 2 519-AC7 PK - 18 XK 387-6546 03 XMSN - STANDARD SHIFT G
L998-KP14 OR- 18
P993-KP34 OR - 18
578-KP3 BU- 18 578-KP3 BU- 18 1 578-KL1 BU- 18
578-KL1 BU- 18 1 578-KT1 BU- 14 200-KT8 BK- 14 E
CONN 31 FR-C1 FR-C2
A L999-KP15 GN- 18 200-KP26 BK- 18
L998-KP28 OR- 18
200-KP26 BK- 18
L998-KP28 OR- 18
2
3
200-KL5 BK- 18
L998-KL10 OR- 18 200-KL14 BK- 18 2
3
200-KT2 BK- 16 578-KT1 BU- 14 578-KT1 BU- 14 200-KT7 BK- 14 F
G
(122) THERMOSTAT SW
3E-5464
3463507 1552273
TURN
XN 474-5003 00 FACE FAN G,J A
L999-KP30 GN - 18 L999-KP30 GN - 18 4 L999-KL13 GN- 18 L998-KL10 OR- 18 L998-KT3 OR- 16 T A 611-FR4 PU- 16 606-FR1 GY- 18 1 BU
8 1 3 4 6 10 (110) BROOM ANGLE SW L999-KL13 GN- 18 4 L999-KT4 GN- 16 L998-KT3 OR- 16 L998-KT10 OR- 14 H NOTE S CONN 9 B 200-FR2 BK- 14 200-FR2 BK- 14 2 BK
779-KP18 WH- 18 779-KP18 WH- 18 5 779-KL3 WH- 18 POSN THIS SCHEMATIC IS FOR THE 420F2, 428F2, 430F2, 432F2, 434F2 AND 444F2 BACKHOE LOADER ELECTRICAL SYSTEM
MOM
MOM
387-6593 6 5 L998-KT11 OR- 16 CONNECTS TO PL-C1 C 619-FR5 GN- 16 618-FR3 YL - 18 3 BR

7 6 VOL 1 LOC C-11 D 618-FR3 YL - 18 611-FR4 PU- 16 4 RD
200-KL14 BK- 18
8 L999-KT12 GN- 16 KT-C4 AC-C9 E 606-FR1 GY- 18 5
HIGH
LOW VOLUME 2 of 3: CHASSIS
KP-C10 200-KL15 BK- 18
CONN 28 L999-KT4 GN- 16 L999-KT13 GN- 14 7N7781 1779654 619-FR5 GN- 16 6 GN
7 2 5 9 1429117 CONN 27 200-KT9 BK- 16 1
(67) MOTOR SPEED RESISTOR
1 C568-AC17 WH- 12 MEDIA NUMBER: UENR5149-01
KL-C2 L998-KT11 OR- 16 2 CONN 30 384-7501
2 516-AC18 GN- 14
L999-KT12 GN- 16 3 3 517-AC19 BU - 14
143-KP42 BR - 18
1552269
1 4
RH HEADLIGHT AS
RH DIP 195-0189
779-KL3 WH- 18 (84) LOADER QC SOL
202-KP38 BK - 18 200-KL15 BK- 18 2 389-3093 LH DIP 195-0191 Components are shown installed on a fully operable machine with the key and engine off, transmission shifter
202-KP47 BK - 18 in neutral and with parking brake set.
QUICK COUPLER PLATFORM - ATCH QUICK COUPLER LOADER - ATCH QUICK COUPLER BROOM HARN - ATCH HVAC - ATCH ROADING LIGHT - RIGHT (SS ONLY) Refer to the appropriate Service Manual for Troubleshooting, Specifications and Systems Operations.
(PILOTS ONLY) Refer to the Parts Manual using a specific serial number prefix in SIS before ordering parts from this schematic.
16 15 14 13 12 11 10 9 8 7 6 5 4 3 2 1
UENR5149-01
January 2018
179
186
210
183
CONN 63 165
227

215 181
159 Connector Location
167 CONN 18 Schem atic
Connector Num ber
Location
211 CONN 1 F-6, C-6
174 CONN 2 E-6, B-6
CONN 7 H-8
212 CONN 8 H-10, D-10
173
420F2, 428F2, 430F2, 432F2,
CONN 18 F-4
182 CONN 21 I-8
434F2 and 444F2 Backhoe Loader

203 CONN 24 B-10
CONN 26 E-8
175
202 CONN 36 H-2 Electrical System
CONN 60 B-8, J-1
CONN 61 CONN 61 F-2 420F2: 428F2: 430F2: 432F2:
CONN 62 D-2 LYB1-546 LYG1-1833 LYD1-194 LYJ1-582
CONN 63 D-2 LYC1-444 LYE1-202
CONN 107 H-8 LBS1-457
CONN 121 I-6
36 Page,
The connectors show n in this chart are for harness to 434F2: 444F2:
harness connectors. Connectors that join a harness to a LYK1-328 LYL1-360
component are generally located at or near the
160 205 component. See the Component Location Chart.
161 222
209 204
CONN 62 180
206
164
168
169
Volume 3 of 3: Engine, Rear Chassis and Side Console
LH ENGINE VIEW RH ENGINE VIEW © 2018 Caterpillar, All Rights Reserved Printed in U.S.A.

163 162 Symbols
156 155 Component Location

Pressure
Symbol
Temperature
Symbol
Level
Symbol
Flow
Symbol
Circuit Breaker
Symbol
Schem atic Machine Schem atic Machine
Com ponent Com ponent
Location Location Location Location Symbols and Definitions
Alarm - Action 1 G-14 155 Solenoid - Pattern Changer 2 C-8 198
231 230 Alarm - Action 2 B-14 156 Solenoid - Secondary Lock H-6 199 Fuse: A component in an electrical circuit that will open the circuit if too much current flows
through it.
Alarm - Backup 1 F-8 157 Solenoid - Side Shift Lock F-8 200
Alarm - Backup 2 C-8 158 Solenoid - Wedge H-6 201
Switch (Normally Open): A switch that will close at a specified point (temp, press, etc.). The
CONN 24 Alternator (120A)
Battery - STD 1 & HD 1
C-2
C-4
159
160
Stud - Jump Start 1
Stud - Jump Start 2
D-3
B-3
202
203
circle indicates that the component has screw terminals and a wire can be disconnected from it.
Battery - STD 2 & HD 2 B-4 161 Stud - Pow er 1 C-3 204 Switch (Normally Closed): A switch that will open at a specified point (temp, press, etc.).
Cluster - Instrument 1 I-14 162 Stud - Pow er 2 B-3 205 No circle indicates that the wire cannot be disconnected from the component.
221 220 Cluster - Instrument 2

Clutch - A/C Compressor
C-14
F-1
163
164
Suppressor - HVAC
Suppressor - Pattern Changer
F-1
C-8
206
207 Ground (Wired): This indicates that the component is connected to a grounded wire. The
grounded wire is fastened to the machine.
Glow Plugs C-1 165 Suppressor - Side Shift Lock F-8 208
Ground - Cab Roof I-2 166 Sw itch - A/C Refrigerant Pressure F-1 209
Ground - Engine F-3 167 Sw itch - Air Filter E-2 210 It is grounded by being fastened to the machine.
240 217 239 216 Ground Strap - Cab / Frame / Engine 1 C-3 168 Sw itch - Battery Disconnect 1 C-4 211
Ground Strap - Cab / Frame / Engine 2 A-3 169 Sw itch - Battery Disconnect 2 A-4 212 Reed Switch: A switch whose contacts are controlled by a magnet. A magnet closes the
Handle - LH Operator 1 B-8 170 Sw itch - Beacon 1 G-13 213 contacts of a normally open reed switch; it opens the contacts of a normally closed reed switch.
Handle - LH Operator 2 B-7 171 Sw itch - Beacon 2 B-13 214
Handle - RH Operator D-8 172 Sw itch - Cold Start Adv D-2 215 Sender: A component that is used with a temperature or pressure gauge. The sender
Heater - Block (120V) D-4 173 Sw itch - Control Flow (7-8) 1 I-13 216 measures the temperature or pressure. Its resistance changes to give an indication to
T
the gauge of the temperature or pressure.
Heater - Block (230V) E-4 174 Sw itch - Control Flow (7-8) 2 E-13 217
Horn - Front D-1 175 Sw itch - Control Pattern 1 H-13 218
CONN 8 CONN 8 Horn - Rear
Module - Bluetooth
F-8
J-6
176
177
Sw itch - Control Pattern 2
Sw itch - Eco Mode 1
D-13
J-13
219
220
It has a coil that makes an electromagnet when current flows through it. The
electromagnet can open or close the switch part of the relay.
Module - Rear Quick Coupler Control G-8 178 Sw itch - Eco Mode 2 E-13 221
Motor - Fuel Lift Pump C-2 179 Sw itch - Engine Oil Pressure E-2 222 Solenoid: A solenoid is an electrical component that is activated by electricity. It has a
219 218 Motor - Starter C-2 180 Sw itch - Front Work Lamp (ATCH) 1 I-13 223 coil that makes an electromagnet when current flows through it. The electromagnet
Sender - Coolant Temperature E-2 181 Sw itch - Front Work Lamp (ATCH) 2 C-13 224 can open or close a valve or move a piece of metal that can do work.
Sender - Fuel Level E-2 182 Sw itch - Hazard 1 G-13 225
Magnetic Latch Solenoid: A magnetic latch solenoid is an electrical component that is
Sensor - Hydraulic Oil Temperature F-2 183 Sw itch - Hazard 2 B-13 226
Sensor - LH Stab G-8 184 Sw itch - Hydraulic Oil Filter Bypass G-2 227 that make electromagnet when current flows through them. It also has an internal switch that places
Sensor - RH Stab E-8 185 Sw itch - Implement Lockout 1 F-13 228 the latch coil circuit open at the time the coil latches.
Sensor - Water In Fuel F-2 186 Sw itch - Implement Lockout 2 A-13 229
Solenoid - Cold Start Adv *NOT SHOWN D-2 187 Sw itch - Key 1 G-14 230 Harness and Wire Symbols
Solenoid - Fuel Shutoff (N / A) *NOT SHOWN D-2 188 Sw itch - Key 2 B-14 231
Wire, Cable, or Harness Harness Identification Letter(s):
Solenoid - Fuel Shutoff (Turbo) *NOT SHOWN D-2 189 Sw itch - Pow er Side Shift C-13 232 Assembly Identification: Includes (A, B, C, ..., AA, AB, AC, ...)
Solenoid - Hoe Aux (Valve 1) 1 D-8 190 Sw itch - Rear Horn D-13 233 Harness Identification Letters and
Harness Connector Serialization Code:
Solenoid - Hoe Aux (Valve 1) 2 D-8 191 Sw itch - Rear Quick Coupler 1 H-6 234 The "C" stands for "Connector" and the
Codes (see sample).
Solenoid - Hoe Aux (Valve 2) 1 A-8 192 Sw itch - Rear Quick Coupler 2 G-6 235 number indicates which connector in the
AG-C4 L-C12 harness (C1, C2, C3, ...).
Solenoid - Hoe Aux (Valve 2) 2 A-8 193 Sw itch - Rear Work Lamp (ATCH) 1 H-13 236 L-C12
111-7898 3E-5179 3E-5179
Solenoid - Implement Lockout C-8 194 Sw itch - Rear Work Lamp (ATCH) 2 C-13 237
Solenoid - Loader Aux 1 B-8 195 Sw itch - Side Shift Lock C-13 238 Part Number: for Connector Plug 1
Solenoid - Loader Aux 2 B-8 196 Sw itch - Start Aid 1 H-13 239
233 Solenoid - Pattern Changer 1 C-8 197 Sw itch - Start Aid 2 E-13 240
2
232
238 Plug Receptacle
237 236 5A
224 223 1 Deutsch connector: Typical representation
9X-1123
Component
214 213 2
of a Deutsch connector. The plug contains all
sockets and the receptacle contains all pins.
Fuse (5 Amps) Part Number
226 225 325-AG135 PK-14

229 228 1 Sure-Seal connector: Typical representation
of a Sure-Seal connector. The plug and receptacle
Harness identification code:
This example indicates wire group 325, Wire Gauge
2 contain both pins and sockets. wire 135 in harness "AG". Wire Color
SS SIDE CONSOLE CP SIDE CONSOLE
178 234 235 170 171 172 158 CONN 36
CONN 60
208 166
CONN 1 184
CONN 1 185
CONN 2 157
CONN 2
CONN 26
CONN 7
CONN 107
RH CONSOLE
190
CONN 21
194 177
D NOT SHOWN
192
CONN 121
RH FRAME
200
RH FRAME
176
201 199
195
197
196
198 193
VIEW OF AREA “D”
207 191
REAR WIRING (420F & 430F) REAR WIRING (428F & 434F AUTOSHIFT ONLY) CAB ROOF AND BLUETOOTH WIRING
14 13 12 11 10 9 8 7 6 5 4 3 2 1
LR-C2
J (177) BLUETOOTH MODULE
478-3877
2407874 J
REVERSE LAMP LH 1 321-LR2 BR - 0.75
262-4728 2 200-LR6 BK - 0.75
H6 H6 1
200-LR6 BK - 0.75
2 LR-C1
614-CF60 PU - 0.75 200-LR7 BK - 0.75 200-LR5 BK - 1.00
3 2813121
E711-CF84 OR - 0.75 200-LR8 BK - 0.75
4
133-CF51 OR - 0.75 PH-C3 5 GND
LR-C3 321-LR1 BR - 1.00 A CONN 60
2407874 321-LR3 BR - 0.75 617-LR4 BR - 0.75 B CONNECTS TO RN-C16
8 1 3 4 6 10 1762946 6 CAN POS
(220) ECO MODE SWITCH 1 REVERSE LAMP RH 1 321-LR3 BR - 0.75 321-LR2 BR - 0.75 321-LR1 BR - 1.00 200-LR5 BK - 1.00 C VOL 3 LOC B-8
125-PH6 RD - 0.75 1 BK 7
MOM
460-0776 262-4728 2 200-LR7 BK - 0.75
F711-PH12 YL - 0.75 2 BK 8
617-LR4 BR - 0.75 617-LR4 BR - 0.75
F712-PH13 GN - 0.75 3 BK 9
202-PH2 BK - 0.75 4 BK 10
CF-C3 11
7 2 5 9 2285856 LR-C4
12 2458026
13
H466-CF13 BU - 0.75 105-CF64 RD - 1.00 133-CF51 OR - 0.75 133-CF47 OR - 0.75 LICENSE PLATE LAMP 1 617-LR4 BR - 0.75
14 CAN NEG
J878-CF83 YL - 0.75 106-CF7 RD - 0.75 133-CF52 OR - 0.75 437-1159 2 200-LR8 BK - 0.75
15
202-CF81 BK - 0.75 133-CF52 OR - 0.75
16 +12V
202-CF2 BK - 0.75 105-CF64 RD - 1.00 105-CF64 RD - 1.00
202-CF8 BK - 0.75 106-CF7 RD - 0.75 106-CF7 RD - 0.75 PH-C1
614-CF66 PU - 0.75 202-CF28 BK - 0.75 116-CF22 BR - 1.00 116-CF22 BR - 1.00 2712809 LICENCE PLATE AND REVERSE LIGHTS - ATCH (BRAZIL ONLY)
M936-CF72 BR - 0.75 307-CF56 OR - 0.75 117-CF23 YL - 1.00 117-CF23 YL - 1.00 1 125-PH4 RD - 0.75 125-PH4 RD - 0.75 125-PH5 RD - 0.75
M937-CF69 GN - 0.75 308-CF61 YL - 1.00 131-CF40 BR - 1.00 131-CF40 BR - 1.00 2 202-PH1 BK - 0.75 125-PH6 RD - 0.75
309-CF50 GY - 0.75 143-CF39 BR - 1.00 143-CF39 BR - 1.00 3 308-PH7 YL - 0.75 PH-C2
8 1 3 4 6 10 (216) CONTROL FLOW (7-8) SWITCH 1 H6 310-CF59 PU - 0.75 144-CF30 GN - 1.00 144-CF30 GN - 1.00 4 202-PH1 BK - 0.75 202-PH2 BK - 0.75 3313578
387-6528 157-CF35 YL - 1.00 157-CF35 YL - 1.00
MOM
CONN 21 5 202-PH3 BK - 0.75 125-PH5 RD - 0.75 1
404-CF76 YL - 0.75 158-CF34 BR - 1.00 158-CF34 BR - 1.00 6 202-PH3 BK - 0.75 2 CONN 121
CONTROL PATTERN SW 405-CF55 GY - 0.75 159-CF4 BU - 1.00 159-CF4 BU - 1.00 CONNECTS TO PL-C38 7 308-PH7 YL - 0.75 308-PH7 YL - 0.75 308-PH7 YL - 0.75 3 TO PROD LINK 631
PATTERN DESCRIPTION SW CF-C8 420-CF79 OR - 0.75 161-CF5 RD - 1.00 161-CF5 RD - 1.00 VOL 1 LOC F-5 8 4 12-PIN CONNECTOR
7 2 5 9 2285856 439-CF58 YL - 0.75 9 F711-PH8 YL - 0.75 F711-PH10 YL - 0.75 5 VOL 2 LOC E-5
1 HEX 2&3 AND 5&6 LH BEACON SOCKET
441-CF17 OR - 0.75 200-CF19 BK - 0.75 10 F711-PH12 YL - 0.75 6 OR RF-C11 9R-7941
2 BHL 2&1 AND 5&4 J878-CF65 YL - 0.75 447-CF16 PU - 0.75 200-CF24 BK - 0.75 200-CF49 BK - 1.00 11 F711-PH8 YL - 0.75 7 TO PROD LINK 641 1237615
202-CF67 BK - 0.75 450-CF57 YL - 0.75 200-CF41 BK - 1.00 12-PIN CONNECTOR 1
12 F712-PH9 GN - 0.75 F712-PH9 GN - 0.75 F712-PH11 GN - 0.75 8 603-RF36 PK - 18 LH BEACON STROBE ATCH
452-CF71 PU - 0.75 F712-PH13 GN - 0.75 9 VOL 2 LOC D-5 200-RF26 BK - 18 140-3668
568-CF80 GN - 0.75 202-CF2 BK - 0.75 10 OR 2
614-CF33 PU - 0.75 614-CF74 PU - 0.75 202-CF8 BK - 0.75 CONNECTS TO PA-C1
I 607-CF36
620-CF37
PK - 1.00
WH - 1.00
C510-CF9
F420-CF73
WH - 0.75
GN - 0.75
202-CF28
202-CF21
BK - 0.75
BK - 0.75
F711-PH10
F712-PH11
YL - 0.75
GN - 0.75
11
12 VOL 2 LOC D-9 I
(162) INSTRUMENT CLUSTER 1
441-4893 CF-C14 G423-CF77 PU - 0.75 202-CF31 BK - 0.75 200-RF18 BK - 12
8 1 3 4 6 10 (223) FRONT WORK LAMP SWITCH (ATCH) 1 T907-CF11 GN - 0.75 202-CF44 BK - 0.75
3402564 200-RF2 BK - 18 200-RF25 BK - 12
+12V BATTERY 1 106-CF7 RD- 0.75 387-6553 202-CF48 BK - 0.75 200-RF6 BK - 18
GROUND 2 202-CF8 BK - 0.75 (8 LIGHT) 200-RF8 BK - 18
202-CF32 BK - 0.75 RF-C12
+12V KEY SWITCH 3 133-CF52 OR- 0.75
202-CF48 BK - 0.75 202-CF12 BK - 0.75
PRODUCT LINK BLUETOOTH ADAPTER - ATCH 1552272
200-RF10 BK - 18 (166) CAB ROOF GROUND
ALT "W" (TACHO) 4 450-CF57 YL - 0.75 CF-C1 200-RF12 BK - 18
ENG COOLANT TEMP 5 441-CF17 OR- 0.75 7 2 5 9 2285856 202-CF62 BK - 0.75 202-CF15 BK - 0.75 STOP 1 604-RF4 OR - 18 200-RF14 BK - 18 NOTE A
FUEL LEVEL 6 447-CF16 PU - 0.75 202-CF67 BK - 0.75 LH STOP TAIL TURN LAMP TURN 2 605-RF1 YL - 18 200-RF17 BK - 18
TORQUE CONV TEMP 7 452-CF71 PU - 0.75 157-CF35 YL - 1.00 202-CF81 BK - 0.75 336-9096 GND 3 200-RF2 BK - 18 RF-C13
158-CF34 BR - 1.00 CF-C9 3E3364
NOT USED 8 TAIL 4 617-RF3 BR - 18 200-RF21 BK - 18
202-CF32 BK - 0.75 307-CF56 OR - 0.75 307-CF56 OR - 0.75 4580607
HYD OIL HI TEMP 9 404-CF76 YL - 0.75 200-RF23 BK - 18 605-RF41 YL - 18 1 RD-18 FRONT LH TURN LAMP
NOT USED 10 308-CF61 YL - 1.00 308-CF61 YL - 1.00 A1
200-RF26 BK - 18 200-RF44 BK - 18 2 BK-18 387-6684
ALT "D+" 11 309-CF50 GY- 0.75 116-CF22 BR - 1.00 309-CF50 GY - 0.75 309-CF50 GY - 0.75 A2
200-RF17 BK - 18 200-RF44 BK - 18
ENG OIL LO PRESSURE 12 405-CF55 GY- 0.75 614-CF75 PU - 0.75 117-CF23 YL - 1.00 A3
200-RF20 BK - 18
NOT USED 13 608-CF26 GN - 1.00 131-CF40 BR - 1.00 310-CF53 PU - 0.75 A4 RF-C3 200-RF22 BK - 18 RF-C7
ACTION LAMP 14 F420-CF73 GN- 0.75 630-CF27 GY - 1.00 133-CF51 OR - 0.75 310-CF59 PU - 0.75 310-CF54 PU - 0.75 A5 1552269 200-RF24 BK - 18 1552269
START AID 15 310-CF59 PU - 0.75 143-CF39 BR - 1.00 A6
REAR LH LONG BEAM (ATCH) 1 630-RF5 GY - 18 200-RF25 BK - 12 620-RF31 WH - 18 1 FRONT LH LONG BEAM ATCH
8 1 3 4 6 10 (236) REAR WORK LAMP SWITCH (ATCH) 1 144-CF30 GN - 1.00 404-CF76 YL - 0.75 404-CF76 YL - 0.75 A7 214-2969 2 200-RF6 BK - 18 200-RF45 BK - 18 200-RF23 BK - 18 2 214-2969
36 Page,
AIR FILTER BLOCKED 16 420-CF79 OR- 0.75

WATER IN FUEL 17 439-CF58 YL - 0.75 387-6555 157-CF35 YL - 1.00 405-CF55 GY - 0.75 405-CF55 GY - 0.75 A8
HYD OIL FILTER BYPASS 18 G423-CF77 PU - 0.75 (8 LIGHT) 158-CF34 BR - 1.00 420-CF79 OR - 0.75 420-CF79 OR - 0.75 A9
200-RF18 BK - 12
TACHO CODE 1 19 159-CF4 BU - 1.00 439-CF58 YL - 0.75 439-CF58 YL - 0.75 105-CF64 RD - 1.00 A10 RF-C2 200-RF19 BK - 14 RF-C6
NOT USED 20 CF-C2 161-CF5 RD - 1.00 441-CF17 OR - 0.75 441-CF17 OR - 0.75 202-CF15 BK - 0.75 A11 1552269 200-RF39 BK - 14 1552269
BACK-LIGHT 21 614-CF74 PU - 0.75 7 2 5 9 2285856 200-CF19 BK - 0.75 447-CF16 PU - 0.75 447-CF16 PU - 0.75 308-CF61 YL - 1.00 A12
REAR LH WIDE FLOOD (STD) 1 608-RF7 GN - 18 607-RF27 PK - 18 1 FRONT LH WIDE FLOOD STD
200-CF24 BK - 0.75 450-CF57 YL - 0.75 450-CF57 YL - 0.75 200-CF49 BK - 1.00 B1 KV-C7 KV-C1 214-2968 2 200-RF8 BK - 18 603-RF36 PK - 18 200-RF21 BK - 18 2 214-2968
ACTION ALARM OUTPUT 22 P789-CF1 PK - 0.75 3463510 1552269
AIR CON SHUT-OFF 23 C510-CF9 WH- 0.75 117-CF23 YL - 1.00 200-CF41 BK - 1.00 452-CF71 PU - 0.75 452-CF71 PU - 0.75 614-CF63 PU - 0.75 B2
603-RF38 PK - 18
ACTION ALARM INPUT 24 568-CF80 GN- 0.75 116-CF22 BR - 1.00 202-CF21 BK - 0.75 518-CF20 OR - 1.00 518-CF20 OR - 1.00 450-CF57 YL - 0.75 B3 A 122-KV21 BU - 12 122-KV21 BU - 12 779-KV12 WH - 18 1 (201) WEDGE SOLENOID 603-RF37 PK - 16
TACHO CODE 2 25 202-CF28 BK - 0.75 202-CF44 BK - 0.75 202-CF31 BK - 0.75 537-CF18 GN - 0.75 537-CF18 GN - 0.75 143-CF39 BR - 1.00 B4 B 614-KV6 PU - 18 M739-KV4 YL - 18 2 368-1278 RF-C4 RF-C9
STAB LEG ALARM 26 T907-CF11 GN- 0.75 202-CF32 BK - 0.75 568-CF80 GN - 0.75 568-CF80 GN - 0.75 F420-CF73 GN - 0.75 B5 C C568-KV22 WH - 12 1552269 604-RF4 OR - 18 1552269
202-CF44 BK - 0.75 603-CF29 PK - 1.00 603-CF29 PK - 1.00 158-CF34 BR - 1.00 B6 CONN 7 D 519-KV24 PK - 18 124-KV2 GN - 18 124-KV18 GN - 18 REAR RH WIDE FLOOD (STD) 1 608-RF9 GN - 18 604-RF16 OR - 18 604-RF35 OR - 18 607-RF29 PK - 18 1 FRONT RH WIDE FLOOD STD
R762-CF43 GY - 1.00 202-CF48 BK - 0.75 605-CF10 YL - 0.75 605-CF10 YL - 0.75 157-CF35 YL - 1.00 B7 CONNECTS TO PL-C35 E C568-KV23 WH - 12 124-KV7 GN - 18 214-2968 2 200-RF10 BK - 18 200-RF22 BK - 18 2 214-2968
R763-CF42 BU - 1.00 606-CF6 GN - 0.75 606-CF6 GN - 0.75 441-CF17 OR - 0.75 B8 VOL 1 LOC D-16 F KV-C2 605-RF1 YL - 18 605-RF41 YL - 18
202-CF62 BK - 0.75 607-CF36 PK - 1.00 607-CF36 PK - 1.00 116-CF22 BR - 1.00 B9 NOTE L G 515-KV25 GY - 18 200-KV3 BK - 12 1552269 605-RF40 YL - 18
8 1 3 4 6 10 (218) CONTROL PATTERN SWITCH 1 202-CF67 BK - 0.75 608-CF26 GN - 1.00 608-CF26 GN - 1.00 117-CF23 YL - 1.00 B10 RF-C5 RF-C8
H 200-KV26 BK - 12 200-KV15 BK - 12 200-KV1 BK - 18 780-KV13 PU - 18 1 (199) SECONDARY LOCK SOLENOID
387-6522 202-CF81 BK - 0.75 447-CF16 PU - 0.75 B11 J 124-KV7 GN - 18 200-KV9 BK - 18 200-KV11 BK - 18 M740-KV5 PK - 18 2 368-1278 1552269 606-RF13 GY - 18 606-RF42 GY - 18 1552269
H NOTE D 310-CF53
518-CF20
PU - 0.75
OR - 1.00
614-CF3
614-CF25
PU - 0.75
PU - 0.75 614-CF63 PU - 0.75
J878-CF78 YL - 0.75 B12
C1
K 200-KV15 BK - 12
200-KV26 BK - 12
REAR RH LONG BEAM (ATCH)
214-2969
1
2
630-RF11
200-RF12
GY - 18
BK - 18
606-RF43 GY - 18 620-RF32
200-RF24
WH - 18
BK - 18
1
2
FRONT RH LONG BEAM ATCH
214-2969
H
CF-C5 537-CF18 GN - 0.75 614-CF38 PU - 0.75 C2 R762-KV10 GY - 18 607-RF27 PK - 18
7 2 5 9 2285856 614-CF68 PU - 0.75 C3 KV-C6 515-KV25 GY - 18 R762-KV17 GY - 18 607-RF29 PK - 18
603-CF29 PK - 1.00 614-CF33 PU - 0.75 630-CF27 GY - 1.00 C4 3463500 607-RF28 PK - 16 RF-C14
200-CF41 BK - 1.00 605-CF10 YL - 0.75 614-CF66 PU - 0.75 106-CF7 RD - 0.75 C5 A 122-KV21 BU - 12 519-KV24 PK - 18 8 1 3 4 6 10 3E3364
131-CF40 BR - 1.00 606-CF6 GN - 0.75 144-CF30 GN - 1.00 C6 B 614-KV19 PU - 18 (234) REAR QUICK COUPLER SWITCH 1 RF-C10 608-RF7 GN - 18 608-RF33 GN - 16 606-RF42 GY - 18 1 RD-18 FRONT RH TURN LAMP
607-CF36 PK - 1.00 614-CF38 PU - 0.75 R762-CF43 GY- 1.00 C7 C C568-KV22 WH - 12 387-6675 1552272 608-RF9 GN - 18 200-RF45 BK - 18 2 BK-18 387-6684
H6 608-CF26 GN - 1.00 614-CF75 PU - 0.75 R763-CF42 BU- 1.00 C8 CONN 107 D 519-KV24 PK - 18 614-KV6 PU - 18 614-KV20 PU - 18 STOP 1 604-RF16 OR - 18
614-CF68 PU - 0.75 614-CF3 PU - 0.75 614-CF74 PU - 0.75 307-CF56 OR - 0.75 C9 CONNECTS TO AC-C7 E C568-KV23 WH - 12 614-KV19 PU - 18 KV-C3 RH STOP TAIL TURN LAMP TURN 2 606-RF13 GY - 18 617-RF3 BR - 18 617-RF3 BR - 18
310-CF53 PU - 0.75 614-CF25 PU - 0.75 614-CF60 PU - 0.75 607-CF36 PK - 1.00 C10 VOL 2 LOC B-6 F 7 2 5 9 1429117 336-9096 GND 3 200-RF14 BK - 18 618-RF15 YL - 18 618-RF15 YL - 18 RF-C1
614-CF33 PU - 0.75 608-CF26 GN - 1.00 C11 NOTE L G 515-KV25 GY - 18 779-KV12 WH - 18 779-KV12 WH - 18 TAIL 4 618-RF15 YL - 18 1552252
8 1 3 4 6 10 (239) START AID SWITCH 1 614-CF38 PU - 0.75 620-CF37 WH - 1.00 620-CF37 WH - 1.00 133-CF47 OR - 0.75 C12
CONN 8 H 200-KV26 BK - 12 780-KV13 PU - 18 780-KV13 PU - 18 200-KV11 BK - 18 620-RF31 WH - 18 605-RF40 YL - 18 1
387-6533 630-CF27 GY - 1.00 630-CF27 GY - 1.00 620-CF37 WH - 1.00 D1
MOM
J 124-KV2 GN - 18 C568-KV22 WH - 12 124-KV18 GN - 18 620-RF32 WH - 18 606-RF43 GY - 18 2

614-CF60 PU - 0.75 C510-CF9 WH - 0.75 C510-CF9 WH - 0.75 C510-CF9 WH - 0.75 D2 CONNECTS TO PL-C13 K 200-KV3 BK - 12 620-RF34 WH - 16 604-RF35 OR - 18 3
614-CF66 PU - 0.75 E711-CF84 OR - 0.75 E711-CF84 OR - 0.75 568-CF80 GN - 0.75 D3 VOL 1 LOC B-16 C568-KV23 WH - 12 618-RF15 YL - 18 4
CF-C6 614-CF68 PU - 0.75 E917-CF45 WH - 0.75 E917-CF45 WH - 0.75 D4 630-RF5 GY - 18 617-RF3 BR - 18 5 CONN 36
2285856 614-CF75 PU - 0.75 E918-CF46 GN - 0.75 E918-CF46 GN - 0.75 310-CF54 PU - 0.75 D5 M739-KV4 YL - 18 M739-KV4 YL - 18 R763-KV16 BU - 18 CONNECTS TO HL-C8
7 2 5 9
614-KV20 PU - 18 630-RF11 GY - 18 630-RF30 GY - 16 200-RF39 BK - 14 6
620-CF37 WH - 1.00 F420-CF73 GN - 0.75 F420-CF73 GN - 0.75 R912-CF70 OR - 1.00 D6 M740-KV5 PK - 18 M740-KV5 PK - 18 200-RF19 BK - 14 7 VOL 2 LOC C-3
200-CF24 BK - 0.75 630-CF27 GY - 1.00 G423-CF77 PU - 0.75 G423-CF77 PU - 0.75 309-CF50 GY - 0.75 D7 (178) REAR QUICK COUPLER CONTROL MODULE KV-C5 8 1 3 4 6 10 603-RF37 PK - 16 8
202-CF62 BK - 0.75 E711-CF84 OR - 0.75 H466-CF13 BU - 0.75 H466-CF13 BU - 0.75 405-CF55 GY - 0.75 D8 361-1160 1552264 R762-KV8 GY - 18 (235) REAR QUICK COUPLER SWITCH 2
387-6676 620-RF34 WH - 16 9
MOM
E917-CF45 WH - 0.75 452-CF71 PU - 0.75 D9 BTRY +VE 1 R762-KV14 GY - 18 R762-KV14 GY - 18 R762-KV10 GY - 18 607-RF28 PK - 16 10
E918-CF46 GN - 0.75 J878-CF14 YL - 0.75 G423-CF77 PU - 0.75 D10 WEDGE SOL + 2 779-KV12 WH - 18 R762-KV17 GY - 18 630-RF30 GY - 16 11
(155) ACTION ALARM 1 + P789-CF1 PK- 0.75 614-CF25 PU - 0.75 H466-CF13 BU - 0.75 J878-CF65 YL - 0.75 J878-CF78 YL - 0.75 439-CF58 YL - 0.75 D11
608-RF33 GN - 16
WEDGE SOL - 3 M739-KV4 YL - 18 12
343-4355 - 202-CF2 BK- 0.75 603-CF29 PK - 1.00 J878-CF14 YL - 0.75 J878-CF83 YL - 0.75 E918-CF46 GN - 0.75 D12 R763-KV16 BU - 18 R763-KV16 BU - 18 KV-C4 RH BEACON SOCKET
SAFETY SOL + 4 780-KV13 PU - 18
J878-CF65 YL - 0.75 E917-CF45 WH - 0.75 E1 7 2 5 9 1429117 178-7539
5
8 1 3 4 6 10 (213) BEACON SWITCH 1 J878-CF83 YL - 0.75 M936-CF72 BR - 0.75 M936-CF72 BR - 0.75 420-CF79 OR - 0.75 E2 GND 6 200-KV9 BK - 18 200-KV1 BK - 18
387-6556 M936-CF72 BR - 0.75 M937-CF69 GN - 0.75 M937-CF69 GN - 0.75 T907-CF11 GN - 0.75 E3 CONTROL SW 7 R763-KV16 BU - 18 603-RF38 PK - 18 RH BEACON ROTATING ATCH
M937-CF69 GN - 0.75 R762-CF43 GY - 1.00 R762-CF43 GY - 1.00 131-CF40 BR - 1.00 E4 R762-KV8 GY - 18
SAFETY SOL - 8 M740-KV5 PK - 18 200-RF20 BK - 18 180-3664
R762-CF43 GY - 1.00 R763-CF42 BU - 1.00 R763-CF42 BU - 1.00 E5
CF-C16 R763-CF42 BU - 1.00 R912-CF70 OR - 1.00 R912-CF70 OR - 1.00 E6 REAR QUICK COUPLER - ATCH
7 2 5 9 2285856 R912-CF70 OR - 1.00 T907-CF11 GN - 0.75 T907-CF11 GN - 0.75 E7
CAB ROOF (CP ONLY)
E8
144-CF30 GN - 1.00 H466-CF13 BU- 0.75 E9
202-CF31 BK - 0.75 M936-CF72 BR- 0.75 E10
M937-CF69 GN - 0.75 E11
G OFF
ON
ST
R CF-C7
1762946 614-CF3 PU - 0.75
603-CF29
605-CF10
PK- 1.00
YL - 0.75
E12
F1 G
C
YL-16 1 308-CF61 YL- 1.00 159-CF4 BU - 1.00 606-CF6 GN - 0.75 F2
OFF
PU-16 2 161-CF5 RD - 1.00 161-CF5 RD- 1.00 F3
S
ON
OR-16 3 307-CF56 OR- 0.75 606-CF6 GN - 0.75 159-CF4 BU- 1.00 F4
ST B
BR-16 4 105-CF64 RD- 1.00 605-CF10 YL - 0.75 518-CF20 OR - 1.00 F5
537-CF18 GN - 0.75 F6 EF-C26
(230) KEY SWITCH 1 8 1 3 4 17 18 202-CF12 BK- 0.75 F7 4529774 (227) HYDRAULIC OIL FILTER BYPASS SWITCH
123-EF23 WH - 0.75 E455-EF10 BR - 1.00
467-8535 (225) HAZARD SWITCH 1 404-CF76 YL - 0.75 F8 449-1641
A1 384-EF50 BU - 3.00 123-EF62 WH - 0.75 123-EF28 WH - 0.75
387-6559 F9 A2 384-EF9 BU - 3.00 123-EF52 WH - 0.75
F10 A3
CF-C15 E711-CF84 OR - 0.75 F11 B1 521-EF14 YL - 0.75 200-EF3 BK - 0.75
10 2 5 7 1387675 F12 B2 405-EF39 GY - 0.75 200-EF46 BK - 2.00 200-EF6 BK - 1.00
G1 RJ-C11
1552267
B3 200-EF30 BK - 1.00
537-CF18 GN - 0.75 G2 B4 200-EF41 BK - 1.00
518-CF20 OR - 1.00 G3 +VE SUPPLY BR A X800-RJ26 OR - 18 B5
(184) LH STAB SENSOR
202-CF21 BK - 0.75 G4 GROUND BU B J764-RJ31 BR - 18 B6 441-EF19 OR - 0.75
387-6626 EF-C3
G5 SIGNAL BK C T907-RJ28 GN - 18 B7
G6
2458026
B8
R912-CF70 OR - 1.00 G7 B9
442-EF11 GY - 0.75 1
(183) HYDRAULIC OIL TEMPERATURE SENSOR
E991-CF82 GY- 1.00 E917-CF45 WH- 0.75 G8 RJ-C3 L740-EF12 BR - 1.00 2
B10 264-4297
E918-CF46 GN - 0.75 G9 1552272 B11 E455-EF10 BR - 1.00 T
G10 LH STOP TAIL TURN LAMP STOP 1 604-RJ13 OR - 18 B12 200-EF46 BK - 2.00
8 1 3 4 6 10 (228) IMPLEMENT LOCKOUT SWITCH 1 G11 387-6627 (LED) TURN 2 605-RJ15 YL - 18 RJ-C1 C1 322-EF26 GY - 0.75
387-6523 G12 (FILAMENT) 336-9096 GND 3 200-RJ3 BK - 18 2253854 C2 202-EF67 BK - 0.75
SEE NOTE X TAIL 4 617-RJ18 BR - 18 C3 447-EF22 PK - 0.75 (167) ENGINE GROUND
1 C4
CF-C4 200-RJ3 BK - 18 605-RJ15 YL - 18 2 C5
7 2 5 9 2285856 200-RJ4 BK - 18 200-RJ2 BK - 14 606-RJ16 GY- 18 3 C6 NOTE A EF-C15 AE-C4 AE-C3
RJ-C4 NOTE N
200-RJ5 BK - 18 617-RJ17 BR- 18 4 C7 2458026 3E3364 1684999
J878-CF14 YL - 0.75 1552269 200-RJ6 BK - 18 367-RJ10 BU- 18 5 (209) A/C REFRIGERANT
C8 521-EF14 YL - 0.75 1 521-AE4 YL - 18 A
143-CF39 BR- 1.00 (200) SIDE SHIFT LOCK SOLENOID BK-18 1 H771-RJ25 BR - 16 200-RJ7 BK - 18 6 C9 202-EF67 BK - 0.75 200-EF41 BK - 1.00 2 513-AE3 OR - 18 B PRESSURE SWITCH
200-CF19 BK- 0.75 257-0478 BK-18 2 200-RJ8 BK - 16 200-RJ8 BK - 16 7 CONN 18 C10 236-6923
604-RJ12 OR- 18 8
CONNECTS TO PL-C30 C11 202-EF4 BK - 0.75 CONN 61
321-RJ22 BR - 18 321-RJ22 BR - 18 9
VOL 1 LOC C-5 C12 202-EF7 BK - 0.75 AE-C2
SIDE CONSOLE (CP ONLY) RJ-C5
367-RJ10 BU - 18 367-RJ10 BU - 18 10 D1 202-EF13 BK - 0.75 1552269
11
F (208) SIDE SHIFT LOCK SUPPRESSOR 1
1552269
H771-RJ24 BR - 16
604-RJ13
604-RJ14
OR - 18
OR - 18
604-RJ12 OR - 18
200-RJ2 BK- 14
12
13
D2
D3
202-EF44 BK - 0.75
202-EF59 BK - 0.75
513-AE5
200-AE6
OR - 18
BK - 18
1
2
BK-14
BK-14
(164) A/C COMPRESSOR CLUTCH
395-2123 F
D4 123-EF62 WH- 0.75
189-3158 2 200-RJ6 BK - 18 14
CONN 1 D5 304-EF64 WH - 3.00 304-EF64 WH - 3.00
605-RJ15 YL - 18 605-RJ15 YL - 18 15 D6 309-EF21 GY - 0.75 309-EF21 GY - 0.75
CONNECTS TO PL-C26
606-RJ16 GY - 18 606-RJ16 GY - 18 321-RJ22 BR- 18 16 D7 322-EF26 GY - 0.75 322-EF26 GY - 0.75
VOL 1 LOC J-16
17 D8 384-EF9 BU - 3.00 384-EF9 BU - 3.00 AE-C1
RJ-C6 617-RJ18 BR - 18 617-RJ17 BR - 18 18 1552269
1552269
D9 384-EF50 BU - 3.00 384-EF50 BU - 3.00
617-RJ19 BR - 18 19 D10 405-EF39 GY - 0.75 405-EF39 GY - 0.75 513-AE1 OR - 18 1 (206) HVAC SUPPRESSOR
(157) BACKUP ALARM 1 + RD-16 1 321-RJ22 BR - 18 20 D11 420-EF60 OR - 0.75 420-EF60 OR - 0.75 200-AE2 BK - 18 2 189-3158
154-5428 - BK-16 2 E747-RJ1 BK - 18 618-RJ20 YL - 18 618-RJ20 YL - 18 21 D12 439-EF16 YL - 0.75 439-EF16 YL - 0.75
627-RJ21 YL - 18 627-RJ21 YL - 18 22 E1 441-EF19 OR - 0.75 441-EF19 OR - 0.75 200-AE7 BK - 18
E747-RJ1 BK - 18 E747-RJ1 BK - 18 23 E2 442-EF11 GY - 0.75 442-EF11 GY - 0.75
E747-RJ1 BK- 18 24 E3 X977-EF8 YL - 1.00 447-EF22 PK - 0.75 447-EF22 PK - 0.75 HVAC - ATCH
H2 H2 H771-RJ24 BR - 16 H771-RJ23 BR - 16 25
614-RH66 PU - 0.75 RJ-C7
E4 450-EF38 YL - 0.75 450-EF38 YL - 0.75 450-EF38 YL - 0.75
H771-RJ25 BR - 16 26 E5 521-EF14 YL - 0.75 521-EF14 YL - 0.75 EF-C16
M936-RH93 BR - 0.75 1552269 27 2698222
M937-RH69 GN - 0.75 E6 309-EF21 GY - 0.75 E455-EF10 BR - 1.00 E455-EF10 BR - 1.00
(176) REAR HORN 1 367-RJ10 BU - 18 J764-RJ9 BR - 18 J764-RJ32 BR - 18 28 E7 L740-EF12 BR - 1.00 L740-EF12 BR - 1.00 123-EF52 WH- 0.75 A PK-18 BATTERY
164-9425 2 200-RJ7 BK - 18 J764-RJ31 BR - 18 618-RJ20 YL - 18 29 (186) WATER IN FUEL SENSOR
8 1 3 4 6 10 E8 X977-EF8 YL - 1.00 X977-EF8 YL - 1.00 202-EF44 BK - 0.75 B BK-18 GROUND
193-0618
(217) CONTROL FLOW 627-RJ21 YL - 18 30 E9 442-EF11 GY - 0.75 439-EF16 YL - 0.75 C YL-18 LAMP
MOM
(7-8) SWITCH 2 T907-RJ28 GN - 18 T907-RJ30 GN - 18 H771-RJ23 BR- 16 31 E10 L740-EF12 BR - 1.00

387-6528 RJ-C8 T907-RJ29 GN - 18 E11 420-EF60 OR - 0.75
NOTE D 1552272 E12 439-EF16 YL - 0.75
RH-C11 RH STOP TAIL TURN LAMP STOP 1 604-RJ14 OR - 18 X800-RJ11 OR - 18 X800-RJ27 OR - 18 F1 EF-C23
7 2 5 9 387-6627(LED) TURN 2 606-RJ16 GY - 18 X800-RJ26 OR - 18 RJ-C2 1761477
2285856 F2
(FILAMENT) 336-9096 GND 3 200-RJ4 BK - 18 3E3382
J878-RH65 YL - 0.75
F3 420-EF60 OR - 0.75 1 (210) AIR FILTER SWITCH
SEE NOTE X TAIL 4 618-RJ20 YL - 18 1 F4 202-EF59 BK - 0.75 2 276-4836
202-RH67 BK - 0.75 2 CONN 2 F5
3 CONNECTS TO PL-C34 F6
T907-RJ30 GN - 18 4 VOL 1 LOC I-16 F7
614-RH12 PU - 0.75 RJ-C10 X800-RJ27 OR - 18 5 EF-C12
F8
E711-RH60 OR - 0.75 1552267 J764-RJ32 BR - 18 6 2458026
F9
133-RH101 OR - 0.75 +VE SUPPLY BR A X800-RJ11 OR - 18
(185) RH STAB SENSOR F10 441-EF19 OR - 0.75 1 (181) COOLANT TEMPERATURE SENDER
GROUND BU B J764-RJ9 BR - 18 F11 202-EF4 BK - 0.75 2 244-3106
8 1 3 4 6 10 (221) ECO MODE SWITCH 2 387-6626 SIGNAL BK C T907-RJ29 GN - 18 F12
MOM
460-0776 T
G1
NOTE D
G2
E RH-C5 RJ-C9
G3 304-EF64 WH - 3.00 EF-C32
2458026
E
7 2 5 9 2285856 105-RH64 RD - 1.00 1552267
405-EF39 GY - 0.75 1 (222) ENGINE OIL PRESSURE SWITCH
106-RH7 RD - 0.75 CONN 26 A 627-RJ21 YL - 18 202-EF13 BK - 0.75 2 237-4894
H466-RH102 BU - 0.75 133-RH52 OR - 0.75 CONNECTS TO LF-1 B 617-RJ19 BR - 18
J878-RH100 YL - 0.75 202-RH2 BK - 0.75 C 200-RJ5 BK - 18
VOL 2 LOC F-15
202-RH13 BK - 0.75 202-RH8 BK - 0.75
307-RH56 OR - 0.75 EF-C10
308-RH61 YL - 1.00 RH-C12 2458026
614-RH68 PU - 0.75 (182) FUEL LEVEL SENDER
310-RH53 PU - 0.75
309-RH72 GY - 0.75 4580607 REAR FRAME (428/434 AUTO MECH ONLY) 1 BK CORD AS 447-EF22 PK - 0.75 1 RD-18 363-8475 (NON-EST)
310-RH59 PU - 0.75 A1 (174) BLOCK HEATER (230V) 202-EF7 BK - 0.75 2 BK-18
219-3271 2 BK 231-3057 362-3089 (EST)
8 1 3 4 6 10
404-RH76 YL - 0.75 A2
(240) START AID SWITCH 2 405-RH55 GY - 0.75 A3
387-6533
MOM
420-RH79 OR - 0.75 133-RH52 OR - 0.75 133-RH51 OR - 0.75 A4

439-RH58 YL - 0.75 133-RH101 OR - 0.75 A5
441-RH17 OR - 0.75 A6 ENGINE BLOCK HEATER (230V)
RH-C9 447-RH16 PK - 0.75 105-RH64 RD - 1.00 105-RH64 RD - 1.00 A7
7 2 5 9 2285856 450-RH57 YL - 0.75 106-RH7 RD - 0.75 106-RH7 RD - 0.75 A8
452-RH84 PU - 0.75 116-RH22 BR - 1.00 116-RH22 BR - 1.00 A9
200-RH24 BK - 0.75 453-RH103 PK - 0.75 117-RH23 YL - 1.00 117-RH23 YL - 1.00 EF-C19 FH-C1 FH-C2
105-RH64 RD- 1.00 A10
202-RH62 BK - 0.75 3463494 3463504 2458026
202-RH15 BK- 0.75 A11
H2 568-RH80 GN - 0.75 131-RH44 BR - 1.00 308-RH61 YL - 1.00 A12 322-EF26 GY - 0.75 A 322-FH1 GY - 0.75 1 (175) FRONT HORN
614-RH92 PU - 0.75 131-RH41 BR - 1.00 131-RH96 BR - 1.00 200-RH73 BK- 1.00 B1 200-EF3 BK - 0.75 B 200-FH2 BK - 0.75 2 164-9425
R762-RH38 GY - 1.00 C510-RH9 WH - 0.75 (173) BLOCK HEATER (120V) 1 BK CORD AS
614-RH63 PU- 0.75 B2
R763-RH39 BU - 1.00 E479-RH98 YL - 0.75 143-RH95 BR - 1.00 143-RH95 BR - 1.00 450-RH57 YL - 0.75 B3 219-3273 2 BK 231-3052 CONN 62
E727-RH28 BU - 0.75 144-RH43 GN - 1.00 144-RH43 GN - 1.00 143-RH95 BR- 1.00
8 1 3 4 6 10 (219) CONTROL PATTERN SWITCH 2 F420-RH86 GN - 0.75 157-RH35 YL - 1.00 157-RH35 YL - 1.00
B4 FRONT HORN
CONTROL PATTERN SW F420-RH86 GN - 0.75 B5
387-6522 G423-RH77 PK - 0.75 158-RH34 BR - 1.00 158-RH34 BR - 1.00 158-RH34 BR- 1.00 B6
PATTERN DESCRIPTION SW NOTE D T907-RH11 GN - 0.75 159-RH6 BU - 1.00 159-RH6 BU - 1.00 157-RH35 YL - 1.00 B7 ENGINE BLOCK HEATER (120V)
1 HEX 2&3 AND 5&6 161-RH5 RD - 1.00 161-RH5 RD - 1.00 441-RH17 OR- 0.75 B8
RH-C16 (172) RH OPERATOR HANDLE RN-C3
2 BHL 2&1 AND 5&4 116-RH22 BR- 1.00 B9
387-6568 3463501 EF-C17 FUEL SHUTOFF WIRE
7 2 5 9 2285856 200-RH19 BK - 0.75 117-RH23 YL - 1.00 B10 2458026 178-8465
200-RH24 BK - 0.75 200-RH73 BK - 1.00 447-RH16 PK- 0.75 B11
5V PWR A 997-RN25 OR- 0.75 (189) FUEL SHUTOFF SOLENOID (TURBO)
200-RH40 BK - 1.00 5V RETURN B T993-RN26 BR - 0.75 123-EF28 WH - 0.75 1 PK-18 A
200-RH40 BK - 1.00 200-RH99 BK - 1.00 J878-RH78 YL - 0.75 B12 200-EF6 BK - 1.00 2 BK-18 B 176-6219
131-RH41 BR - 1.00 C1
RH SLIDER SIGNAL 1 C M962-RN14 YL - 0.75
202-RH2 BK - 0.75 C2
RH SLIDER SIGNAL 2 D M963-RN13 BU - 0.75 CONN 63
D 614-RH81
A305-RH10
PU - 0.75
YL - 0.75
202-RH8 BK - 0.75
202-RH13 BK - 0.75 630-RH27 GY - 1.00
C3
C4
E
F
G
WC-C1
3E3364 D
202-RH47 BK - 0.75 106-RH7 RD - 0.75 C5 CONNECTS TO EF-C17 1 327-WC1 PK - 16 (188) FUEL SHUTOFF SOLENOID (NATURALLY ASPIRATED)
202-RH82 BK - 0.75 144-RH43 GN - 1.00 C6
H K973-RN18 PK - 0.75
8 1 3 4 6 10 (233) REAR HORN SWITCH VOL 3 LOC D-2 2 208-5029
202-RH71 BK - 0.75 R762-RH38 GY - 1.00 C7
J K974-RN19 PU - 0.75
MOM
387-6549 202-RH89 BK - 0.75 K J878-RN20 YL - 0.75

R763-RH39 BU - 1.00 C8
(428/434F2 ONLY) L
307-RH56 OR - 0.75 C9
FUEL SHUT-OFF
202-RH21 BK - 0.75 M
607-RH36 PK - 1.00 C10
RH-C2 202-RH25 BK - 0.75 608-RH26 GN - 1.00 C11
7 2 5 9 2285856 202-RH32 BK - 0.75 133-RH51 OR - 0.75 C12 NOTE A
RN-C4 NOTE Z
202-RH62 BK - 0.75 202-RH15 BK - 0.75 620-RH37 WH - 1.00 D1 CBL-TT1 RD - 2 (TO JUMP START STUD) 123-EF23 WH - 0.75 (187) COLD START ADV SOLENOID
202-RH25 BK - 0.75 (190) HOE AUX VALVE 1 SOLENOID 1 2458026
POWER SS SOLENOID STATUS 202-RH67 BK - 0.75 202-RH49 BK - 0.75 C510-RH9 WH - 0.75 D2 (EMISSIONS ENGINE)
202-RH71 BK - 0.75 202-RH74 BK - 0.75 362-3212 1 T969-RN21 YL - 0.75 NOTE DESCRIPTION TO POWER DISTRIBUTION BOARD T
568-RH80 GN - 0.75 D3
FUNCTION SIDE SHIFT LOCK SIDE SHIFT LEFT SIDE SHIFT RIGHT LOCKOUT
202-RH82 BK - 0.75 H771-RH90 BR - 1.00 D4 CONN 8 PORT B
2 H802-RN27 GY - 0.75 CONNECTS TO X1 STUD CBL-MM1 RD - 00 (215) COLD START ADV SWITCH
STATIONARY OFF OFF OFF OFF
310-RH54 PU - 0.75 D5 CONNECTS TO PL-C13 NOTE A: ASSEMBLE TERMINALS TO DESIGNATED STUD VOL 1 LOC I-4 235-1790
614-RH75 PU - 0.75 307-RH56 OR - 0.75 307-RH56 OR - 0.75 VOL 1 LOC B-16 (202) JUMP START STUD 1
SHIFT LEFT ENERGIZE ENERGIZE OFF ENERGIZE R912-RH70 OR - 1.00 D6
RN-C5
H771-RH91 BR - 1.00 308-RH61 YL - 1.00 308-RH61 YL - 1.00 NOTE B: WHEN FITTED, CONNECT X739-BR TO DOME LIGHT (SH 2 LOC F-4) 106-0800
SHIFT RIGHT ENERGIZE OFF ENERGIZE ENERGIZE 309-RH72 GY - 0.75 D7
2458026
H771-RH18 BR - 1.00 309-RH72 GY - 0.75 309-RH72 GY - 0.75 (191) HOE AUX VALVE 1 SOLENOID 2 EF-C7
405-RH55 GY - 0.75 D8
PWR BEYOND OFF OFF OFF ENERGIZE M719-RH85 GN - 1.00 362-3212 1 T971-RN23 OR - 0.75 NOTE D: NOT USED ON 428/434F2 MODELS NOTE A 2458026
452-RH84 PU - 0.75 D9
M721-RH87 WH - 1.00 310-RH53 PU - 0.75 2 H802-RN28 GY - 0.75 (TO POWER STUD)
G423-RH77 PK - 0.75 D10 PORT A X977-EF8 YL - 1.00 1 (179) FUEL LIFT PUMP MOTOR
116-RH22 BR - 1.00 310-RH59 PU - 0.75 310-RH54 PU - 0.75 NOTE E: CONTACTS CLOSED WHEN BRAKE PEDAL IS DEPRESSED NOTE A NOTE A MOTOR
8 1 3 4 6 10 439-RH58 YL - 0.75 D11 200-EF30 BK - 1.00 2 349-1063
(238) SIDE SHIFT LOCK SWITCH 117-RH23 YL - 1.00 (TO NEG TERM) (TO POS TERM)
E918-RH46 GN - 0.75 D12
MOM
MOM
387-6547 131-RH41 BR - 1.00 404-RH76 YL - 0.75 404-RH76 YL - 0.75 E917-RH45 WH - 0.75 E1 E-STICK (7TH FUNCTION) - ATCH NOTE F: ON AUTO-MECH MACHINES, CONNECT WIRE AS. FROM PIN 2 TO 3 ON CONNECTOR RH-C6. CONN BTRY NEG CONN BTRY POS
NOTE W 133-RH101 OR - 0.75 405-RH55 GY - 0.75 405-RH55 GY - 0.75 331-5574 331-5573 CBL-SS1 RD - 00 EF-C11
420-RH79 OR - 0.75 E2
143-RH95 BR - 1.00 420-RH79 OR - 0.75 420-RH79 OR - 0.75 T907-RH11 GN - 0.75 E3 200-RN39 BK - 1.00 200-RN42 BK - 1.00 NOTE G: OPTION BASED ON MACHINE CONFIGURATION 2219804
RH-C8 144-RH43 GN - 1.00 439-RH58 YL - 0.75 439-RH58 YL - 0.75 131-RH96 BR - 1.00 E4 200-RN41 BK - 0.75 (204) POWER STUD 1
RN-C6 384-EF9 BU - 3.00 384-EF24 BU- 10 1
7 2 5 9 2285856 157-RH35 YL - 1.00 441-RH17 OR - 0.75 441-RH17 OR - 0.75 M719-RH85 GN - 1.00 E5 NOTE H: NOT USED ON PILOT MACHINES 263-6556
2458026 321-RN17 BR - 0.75 321-RN44 BR - 1.00 384-EF50 BU - 3.00
158-RH34 BR - 1.00 447-RH16 PK - 0.75 447-RH16 PK - 0.75 M721-RH87 WH - 1.00 E6
(232) POWER SIDE SHIFT SWITCH
RD- 00
R912-RH83 OR - 1.00 (158) BACKUP ALARM 2 321-RN17 BR - 0.75 321-RN43 BR - 1.00
CBL-EE BK- 00
159-RH6 BU - 1.00 450-RH57 YL - 0.75 450-RH57 YL - 0.75 RD-16 1 NOTE J: ATTACHMENT
387-6539 E727-RH28 BU - 0.75 E7
202-RH74 BK - 0.75 161-RH5 RD - 1.00 452-RH84 PU - 0.75 452-RH84 PU - 0.75 154-5428 BK-16 2 E747-RN36 BK - 0.75
NOTE W A305-RH10 YL - 0.75 E8
200-RH19 BK - 0.75 453-RH103 PK - 0.75 453-RH103 PK - 0.75 H466-RH102 BU - 0.75 E9 617-RN45 BR - 0.75 617-RN45 BR - 0.75 NOTE K: WHEN LOADER LOCKS ARE INSTALLED, REMOVE JUMPER AND CONNECT PL-C46 TO LN-C2 (165) GLOW PLUGS
(163) INSTRUMENT CLUSTER 2 997-RN25 OR - 0.75 997-RN25 OR - 0.75
CBL-AA1
202-RH21 BK - 0.75 518-RH30 OR - 1.00 518-RH30 OR - 1.00 M936-RH93 BR - 0.75 E10 232-6662 (X4)
441-4894 RH-C17 614-RH88 PU - 0.75 RN-C9 A122-RN1 YL - 0.75 A122-RN1 YL - 0.75 NEG POS
3402564 200-RH24 BK - 0.75 537-RH31 GN - 0.75 537-RH31 GN - 0.75 M937-RH69 GN - 0.75 E11 RN-C1 BATTERY (STD) 1
608-RH26 GN - 1.00 2458026 A305-RN12 YL - 0.75 A305-RN12 YL - 0.75
200-RH40 BK - 1.00 568-RH80 GN - 0.75 568-RH80 GN - 0.75 603-RH42 PK - 1.00 E12 3313594 NOTE L: WHEN REAR QUICK COUPLER IS FITTED, CONNECT KV-C7 TO PL-C35 AND CONNECT KV-C6 TO AC-C7. 230-6368
+12V BATTERY 1 106-RH7 RD - 0.75 630-RH27 GY - 1.00 202-RH13 BK - 0.75 603-RH42 PK - 1.00 603-RH42 PK - 1.00 (197) PATTERN CHANGER SOLENOID 1 RD-18 1 R762-RN29 GY - 0.75 C216-RN5 BK - 0.75 C216-RN5 BK - 0.75
605-RH3 YL - 0.75 F1
GROUND 2 202-RH8 BK - 0.75 202-RH25 BK - 0.75 605-RH3 YL - 0.75 605-RH3 YL - 0.75 240-6866 RD-18 2 R763-RN30 BU - 0.75 E543-RN8 WH- 0.75 E543-RN8 WH- 0.75 997-RN25 OR - 0.75 1 CBL-HH1 BK - 00 CBL-GG1 RD - 00
8 1 3 4 6 10 606-RH4 GY - 0.75 F2 309-EF21 GY - 0.75 D+
+12V KEY SWITCH 3 133-RH52 OR - 0.75 (237) REAR WORK LAMP SWITCH (ATCH) 2 202-RH32 BK - 0.75 606-RH4 GY - 0.75 606-RH4 GY - 0.75 E544-RN16 GN - 0.75 E544-RN16 GN - 0.75 2
C ALT "W" (TACHO)
ENG COOLANT TEMP
4
5
450-RH57
441-RH17
YL - 0.75
OR - 0.75
387-6555
(8 LIGHT)
202-RH47
202-RH62
BK - 0.75
BK - 0.75
607-RH36 PK - 1.00
608-RH26 GN - 1.00
607-RH36 PK - 1.00
608-RH26 GN - 1.00
161-RH5 RD - 1.00
159-RH6 BU - 1.00
F3
F4
RN-C11
E747-RN36
G962-RN11
BK - 0.75
OR - 0.75
E747-RN36
G962-RN11
BK - 0.75
OR - 0.75 617-RN45 BR - 0.75
3
4
NOTE M: FOR MACHINES WITHOUT AIR CON REPLACE HEATER AC SW WITH VENT SW.
NEG POS
BATTERY (HD) 1
230-6368
450-EF38 YL - 0.75 W C
518-RH30 OR - 1.00 F5
2458026 B+
FUEL LEVEL 6 447-RH16 PK - 0.75 202-RH67 BK - 0.75 5
537-RH31 GN - 0.75 F6 304-EF64 WH - 3.00 (159) ALTERNATOR (120A)
TORQUE CONV TEMP 7 452-RH84 PU - 0.75 RH-C3 202-RH71 BK - 0.75 614-RH48 PU - 0.75 614-RH63 PU - 0.75 (198) PATTERN CHANGER SOLENOID 2 RD-18 1 R762-RN31 GY - 0.75 H801-RN3 PU - 0.75 H801-RN2 PU - 0.75 T993-RN6 BR - 0.75 6 NOTE N: CONTACTS CLOSED AT PROPER REFRIGERANT CHARGE 383-2557
202-RH49 BK - 0.75 F7 (160) BATTERY - (STD) 1 & HD 1
AWS WARNING 8 453-RH103 PK - 0.75 7 2 5 9 2285856 202-RH74 BK - 0.75 614-RH68 PU - 0.75 240-6866 RD-18 2 R763-RN32 BU - 0.75 H801-RN4 PU - 0.75 M963-RN13 BU - 0.75 7
404-RH76 YL - 0.75 F8
HYD OIL HI TEMP 9 404-RH76 YL - 0.75 8
RD- 2
202-RH82 BK - 0.75 614-RH94 PU - 0.75 F9 NOTE P: FOR MACHINES WITH RIDE CONTROL AND LOADER LOCKS REPLACE RIDE CONT SW WITH (180) STARTER MOTOR
NOT USED 10 117-RH23 YL - 1.00 614-RH33 PU - 0.75 F10 H802-RN27 GY - 0.75 R762-RN9 GY - 0.75 9 RIDE CONT LL SW. NOTE A
309-RH72 GY - 0.75 H2 116-RH22 BR - 1.00 RN-C10 143-0539 (T2)
ALT "D+" 11
202-RH89 BK - 0.75 614-RH66 PU - 0.75 E711-RH60 OR - 0.75 F11 H802-RN28 GY - 0.75 H802-RN15 GY - 0.75 R763-RN10 BU - 0.75 10 FOR MACHINES WITH LOADER LOCKS ONLY REPLACE RIDE CONT SW WITH LOADER LOCK SW. (TO FRAME GROUND)
405-RH55 GY - 0.75 202-RH89 BK - 0.75 2458026 303-5795 (T3)
CBL-CC1
ENG OIL LO PRESS 12 H802-RN37 GY - 0.75 G962-RN11 OR - 0.75 11
310-RH53 PU - 0.75 614-RH75 PU - 0.75 453-RH103 PK - 0.75 F12 CBL-FF BK - 00 304-EF64 WH- 3.00
NOT USED 13
G1
(207) PATTERN CHANGER SUPPRESSOR 1 R762-RN34 GY - 0.75 H802-RN38 GY - 0.75 A305-RN12 YL - 0.75 12 NOTE R: ON MACHINES WITH PILOT HOE CONTROL CONNECT IMP LOCKOUT SWITCH TO CONNECTOR RH-C6. G S
ACTION LAMP INPUT 14 F420-RH86 GN - 0.75 518-RH30 OR - 1.00 614-RH12 PU - 0.75 189-3158 2 R763-RN35 BU - 0.75 200-RN42 BK - 1.00 13 (211) BATTERY DISCONNECT SWITCH 1
START AID 15 310-RH59 PU - 0.75 614-RH33 PU - 0.75
G2
J878-RN20 YL - 0.75 J878-RN20 YL - 0.75 M962-RN14 YL - 0.75 14
CONN 1
537-RH31 GN - 0.75 614-RH20 PU - 0.75 G3 CONNECTS TO PL-C26 NOTE S: THERMOSTAT FITTED TO MACHINES WITH AIR CON ONLY. 7N-0718 8X-9618 134-3355 MOT BTRY
AIR FILTER BLOCKED 16 420-RH79 OR - 0.75 607-RH36 PK - 1.00 603-RH42 PK - 1.00 614-RH81 PU - 0.75 G4 K973-RN18 PK - 0.75 K973-RN18 PK - 0.75 H802-RN15 GY - 0.75 15
WATER IN FUEL 17 439-RH58 YL - 0.75 620-RH37 WH - 1.00 RN-C12 K974-RN19 PU - 0.75 K974-RN19 PU - 0.75 321-RN44 BR - 1.00 16 VOL 1 LOC J-16 CBL-CC1 RD - 2
605-RH3 YL - 0.75 614-RH88 PU - 0.75 614-RH97 PU - 0.75 G5 NOTE T: WHEN BOTH HOSE BURST CHECK VALVE AND OBJECT HANDLING ARE FITTED
HYD FILTER BYPASS 18 G423-RH77 PK - 0.75 (194) IMPLEMENT LOCKOUT SOLENOID 2458026 M947-RN33 OR - 0.75 M947-RN33 OR - 0.75 K973-RN18 PK - 0.75 17 MOTOR
8 1 3 4 6 10
606-RH4 GY - 0.75 614-RH94 PU - 0.75 G6 CONNECT HA-C1 TO RH-C18 AND CONNECT HA-C3 TO TA-C2.
STABILITY WARNING 19 E479-RH98 YL - 0.75 (224) FRONT WORK LAMP SWITCH (ATCH) 2 607-RH36 PK - 1.00 614-RH92 PU - 0.75 373-6995 BK-18 1 G962-RN11 OR - 0.75 M948-RN7 BR - 0.75 M948-RN7 BR - 0.75 K974-RN19 PU - 0.75 18
G7 FRAME CBL-AA1 RD - 00
NOT USED 20 387-6553 608-RH26 GN - 1.00 G8 (INLET) BK-18 2 C216-RN5 BK - 0.75 M962-RN14 YL - 0.75 M962-RN14 YL - 0.75 J878-RN20 YL - 0.75 19 CAB ENGINE
BACK-LIGHT 21 614-RH92 PU - 0.75 (8 LIGHT) 614-RH12 PU - 0.75 620-RH37 WH- 1.00 620-RH37 WH - 1.00 G9 M963-RN13 BU - 0.75 M963-RN13 BU - 0.75 T969-RN21 YL - 0.75 20 NOTE U: FOR MACHINES WITH RIDE CONTROL REMOVE JUMPER AND CONNECT RK-C1 TO PL-C40 (168) CAB/FRAME/ENGINE GROUND STRAP 1
ACTION ALARM OUTPUT 22 P789-RH1 PK - 0.75 614-RH20 PU - 0.75 630-RH27 GY- 1.00 630-RH27 GY - 1.00 G10 T970-RN22 GY - 0.75 21
AIR CON SHUT-OFF 23 C510-RH9 WH - 0.75 R762-RN29 GY - 0.75 NOTE A
RH-C1 614-RH33 PU - 0.75 A305-RH10 YL - 0.75 A305-RH10 YL - 0.75 T971-RN23 OR - 0.75 22
ACTION ALARM INPUT 24 568-RH80 GN - 0.75 2285856
G11
RN-C13 R762-RN31 GY - 0.75 R762-RN9 GY - 0.75 T972-RN24 GN - 0.75 23
BATTERY (NON-EST) (TO POS TERM)
7 2 5 9 614-RH48 PU - 0.75 C510-RH9 WH- 0.75 C510-RH9 WH - 0.75 G12 NOTE V: FOR MACHINES WITH REVERSING LIGHTS (BRAZIL ONLY) REPLACE RELAY LINK AT K16 WITH A MICRO RELAY.
NEUT LOCK IN GEAR ALARM 25 E727-RH28 BU - 0.75 2458026 R762-RN34 GY - 0.75 E747-RN36 BK - 0.75 24 CBL-AA1 RD- 00
614-RH66 PU - 0.75 E479-RH98 YL - 0.75 E479-RH98 YL - 0.75
STAB LEG ALARM 26 T907-RH11 GN - 0.75 157-RH35 YL - 1.00 614-RH68 PU - 0.75 E711-RH60 OR - 0.75 E711-RH60 OR - 0.75 (195) LOADER AUX VALVE SOLENOID 1 RD-18 1 E543-RN8 WH - 0.75 H801-RN2 PU - 0.75 25 NOTE W: FOR POWER SIDESHIFT OPTION, REPLACE SIDE SHIFT LOCK SW WITH POWER SS SW ENGINE
158-RH34 BR - 1.00 614-RH75 PU - 0.75 E727-RH28 BU - 0.75 E727-RH28 BU - 0.75 362-3212 RD-18 2 H801-RN3 PU - 0.75 R763-RN30 BU - 0.75 E543-RN8 WH - 0.75 26
202-RH32 BK - 0.75 614-RH81 PU - 0.75 E917-RH45 WH - 0.75 E917-RH45 WH - 0.75 R763-RN32 BU - 0.75 R763-RN10 BU - 0.75 E544-RN16 GN - 0.75 27 NOTE X: LED LAMPS ARE STANDARD FITMENT ON SS MODELS WITH A CAB VOLUME 3
R763-RN35 BU - 0.75 C216-RN5 BK - 0.75 28 NOTE A
614-RH88 PU - 0.75 E918-RH46 GN - 0.75 E918-RH46 GN - 0.75 (TO JUMP START STUD) IDENT PART NO. CHG DESCRIPTION NOTE
RN-C14 29 CBL-TT1 RD-2
614-RH94 PU - 0.75 F420-RH86 GN - 0.75 F420-RH86 GN - 0.75 NOTE Y: 8TH FUNCTION (HOE AUX) IS A DEALER FIT OPTION ONLY.
614-RH48 PU - 0.75 2458026 T969-RN21 YL - 0.75 T969-RN21 YL - 0.75 30 HARNESS AS.
G423-RH77 PK - 0.75 G423-RH77 PK - 0.75 TO POWER DISTRIBUTION BOARD
603-RH42 PK - 1.00 620-RH37 WH- 1.00 H466-RH102 BU - 0.75 H466-RH102 BU - 0.75 (196) LOADER AUX VALE SOLENOID 2 RD-18 1 E544-RN16 GN - 0.75 T970-RN22 GY - 0.75 T970-RN22 GY - 0.75 31 CONNECTS TO X1 STUD
362-3212 RD-18 2 H801-RN4 PU - 0.75 T971-RN23 OR - 0.75 T971-RN23 OR - 0.75 CBL-PP1 RD - 00 AE 238-7492 04 HVAC AIR CONDITION - ENGINE J
630-RH27 GY - 1.00 NOTE Z: CONNECTION SUPPLIED WITH ENGINE VOL 1 LOC I-4
8 1 3 4 6 10
A305-RH10 YL - 0.75 H771-RH18 BR - 1.00 H771-RH90 BR - 1.00 T972-RN24 GN - 0.75 T972-RN24 GN - 0.75
(203) JUMP START STUD 2 CF 430-5022 02 CONSOLE - SIDE (CP ONLY)
(156) ACTION ALARM 2 + P789-RH1 PK - 0.75 (214) BEACON SWITCH 2 E711-RH60 OR - 0.75 H771-RH91 BR - 1.00
343-4355 - 202-RH2 BK - 0.75 387-6556 RN-C16 T993-RN26 BR - 0.75 T993-RN6 BR - 0.75 RN-C15 106-0800 EF 430-5054 02 ENGINE
E917-RH45 WH - 0.75
2407878 T993-RN40 BR - 0.75 1519276 FH 459-0345 00 FRONT HORN
E918-RH46 GN - 0.75 J878-RH14 YL - 0.75
H466-RH102 BU - 0.75 J878-RH65 YL - 0.75 J878-RH78 YL - 0.75
CONN 60 1 321-RN43 BR - 1.00 M948-RN7 BR - 0.75 1 NOTE A
RH-C7 CONNECTS TO LR-C1 2 617-RN45 BR - 0.75 M947-RN33 OR - 0.75 2 (TO POWER STUD) KV 438-3678 00 REAR QUICK COUPLER J
H771-RH18 BR - 1.00 J878-RH100 YL - 0.75 CONN 2 NOTE A NOTE A
B 7 2 5 9 2285856 H771-RH91
J878-RH14
BR - 1.00
YL - 0.75 M719-RH85 GN - 1.00 M719-RH85 GN - 1.00
VOL 3 LOC J-1 3 200-RN39 BK - 1.00 A122-RN1 YL - 0.75 3
4 CONNECTS TO PL-C34
SYMBOL DESCRIPTION
(TO NEG TERM)
CONN BTRY NEG CONN BTRY POS
(TO POS TERM)
LR
PH
452-6387
452-4268
00
00
LICENCE PLATE & REVERSE LIGHTS (BRAZIL ONLY)
PRODUCT LINK BLUETOOTH MODULE
J
J
B
144-RH43 GN - 1.00 RH-C18 VOL 1 LOC I-16
J878-RH65 YL - 0.75 M721-RH87 WH - 1.00 M721-RH87 WH - 1.00
2610524 CONN 24 5
331-5574 331-5573 CBL-RR1 RD - 00
202-RH47 BK - 0.75 J878-RH100 YL - 0.75 M936-RH93 BR - 0.75 M936-RH93 BR - 0.75 6 RF 387-6631 03 ROOF (CP ONLY)
131-RH44 BR - 1.00 1 CONNECTS TO TA-C2 CIRCUIT CONNECTED
M719-RH85 GN - 1.00 M937-RH69 GN - 0.75 M937-RH69 GN - 0.75 VOL 2 LOC E-12 (205) POWER STUD 2 RH 430-5023 02 CONSOLE - SIDE (SS ONLY)
OFF
R RH-C10 M721-RH87 WH- 1.00 R762-RH38 GY - 1.00 R762-RH38 GY - 1.00 614-RH97 PU - 0.75 2
ON
1762946 614-RH20 PU - 0.75 E479-RH98 YL - 0.75 OR CIRCUIT NOT CONNECTED 263-6556
M936-RH93 BR - 0.75 R763-RH39 BU - 1.00 R763-RH39 BU - 1.00 3
(170) LH OPERATOR HANDLE 1
RJ 430-5059 03 REAR END (428/434F2 AUTOSHIFT MODELS ONLY)
ST
YL-16 1 308-RH61 YL - 1.00 159-RH6 BU - 1.00 200-RH99 BK - 1.00 4 CONNECTS TO HA-C1 RN-C2 (171) LH OPERATOR HANDLE 2
M937-RH69 GN - 0.75
RD- 00
OFF C
PU-16 2 161-RH5 RD - 1.00 R762-RH38 GY - 1.00 R912-RH50 OR - 1.00 R912-RH70 OR - 1.00 VOL 2 LOC D-9 387-6564 3463501 387-6565 ELECTRICAL CONNECTION TO RN 451-9777 01 REAR END (CP ONLY)
S MACHINE STRUCTURE
ON
OR-16 3 307-RH56 OR - 0.75 606-RH4 GY - 0.75 R763-RH39 BU - 1.00 R912-RH83 OR - 1.00 NOTE T 5V PWR A A122-RN1 YL - 0.75 WIRE AS.
ST B
BR-16 4 105-RH64 RD - 1.00 605-RH3 YL - 0.75 R912-RH50 OR - 1.00 5V RETURN B T993-RN40 BR - 0.75 INTERNAL ELECTRICAL CONNECTION NEG POS
BATTERY (STD) 2 WC 246-0568 02 ENGINE SHUTOFF (NON-TURBO ENGINES ONLY) G
CBL-KK1
R912-RH83 OR - 1.00 T907-RH11 GN - 0.75 T907-RH11 GN - 0.75 LH ROLLER SIGNAL 1 C M948-RN7 BR - 0.75 TO SURFACE OF COMPONENT
(231) KEY SWITCH 2 8 1 3 4 17 18 230-6368
LH ROLLER SIGNAL 2 D M947-RN33 OR - 0.75 CABLE AS.
467-8535
CBL-EE1 BK-00
(226) HAZARD SWITCH 2 SW RTN E 200-RN41 BK - 0.75 CONNECTOR CBL-GG1 RD-00
387-6559 HORN SW-NO F A305-RN12 YL - 0.75 SW RTN
AA 368-4714 04 POS (POWER STUD TO STARTER)
NOTE: H#
NEG POS
G HORN SW - NO
FOR MACHINES WITHOUT REAR AUX (8TH FUNCTION) CIRCUIT GROUPING DESIGNATION BATTERY (HD) 2 CC 290-6746 01 POS (STARTER TO ALTERNATOR)
RH-C4 H
USE OPERATOR LEFT JOYSTICK 387-6565 230-6368
10 2 5 7 1387675 J TO STARTER BATTRY TERM EE 331-5555 04 NEG (BATTERY TO DISCONNECT SWITCH)
IMPLEMENT LOCKOUT SW ATCH WIRE, CABLE, COMPONENT (161) BATTERY - (STD) 2 & HD 2 VOL 3 LOC C-2
K FF 331-5556 02 NEG (DISCONNECT SWITCH TO FRAME) G
SWITCH POS CONNECTS LIGHT SOLENOID HYD FLOW 537-RH31 GN - 0.75 L
TOP (UNLOCK) 2&3 AND 5&6 OFF ENERGIZED YES 518-RH30 OR - 1.00 M SPLICE GG 331-5554 05 POS (HEAVY DUTY) J
202-RH21 BK - 0.75 HH 331-5557 05 NEG (HEAVY DUTY) J
BOTTOM (LOCK) 2&1 AND 5&4 ON DE-ENERGIZED NO BLADE, SPADE, RING OR SCREW
RN-C7 TERMINAL NOTE A KK 357-9523 02 POS (POWER STUD TO STARTER) (EST ONLY)
E991-RH29 GY - 0.75 R912-RH50 OR - 1.00 (192) HOE AUX VALVE 2 SOLENOID 1 2458026 (TO FRAME GROUND)
CBL-NN1 BK- 00 MM 387-6669 03 POS (POWER STUD TO JUMP START STUD)
E917-RH45 WH - 0.75 362-3212 1 T970-RN22 GY - 0.75
E918-RH46 GN - 0.75 PORT B 2 H802-RN38 GY - 0.75 NN 387-6490 03 NEG (DISCONNECT SWITCH TO FRAME) (EST ONLY)
(212) BATTERY DISCONNECT SWITCH 2
8 1 3 4 6 10 ABBREV COLOR 7N-0718 8X-9618 134-3355 PP 387-6642 03 POS (POWER STUD TO JUMP START STUD) (EST ONLY)
NOTE F
JUMPER WIRE
165-0312
RN-C8
2458026
WIRE GROUP COLOR DESCRIPTIONS RD RED
RR 369-1751 02 POS (BATTERY TO MAIN POWER STUD) (EST ONLY)
(193) HOE AUX VALVE 2 SOLENOID 2 SS 331-5550 08 POS (BATTERY TO MAIN POWER STUD)
362-3212 1 T972-RN24 GN - 0.75 GROUND CIRCUIT
RH-C6 2 H802-RN37 GY - 0.75 WH WHITE FRAME TT 387-6507 02 POS (JUMP START STUD TO POWER DISTRIBUTION PCB)
PORT A WIRES THAT HAVE SYSTEM VOLTAGE WHEN THE KEY SWITCH IS OFF CAB ENGINE
2285856 STRAP AS.
(229) IMPLEMENT LOCKOUT SWITCH 2
7 2 5 9
WIRES THAT HAVE SYSTEM VOLTAGE WHEN THE KEY SWITCH IS ON
OR ORANGE (169) CAB/FRAME/ENGINE GROUND STRAP 2
387-6523 J878-RH14 YL - 0.75 REAR AUX (8TH FUNCTION) - ATCH BATTERY (EST) 8X-9618 01 STRAP - GROUND CAB TO FRAME
NOTE R 143-RH95 BR - 1.00
STARTING CIRCUIT YL YELLOW
A 200-RH19 BK - 0.75 NOTE Y START AID CIRCUIT PK PINK
134-3355 01 STRAP - GROUND ENGINE TO FRAME A
MACHINE CONTROL CIRCUIT
SIDE CONSOLE (SS ONLY) REAR END (CP ONLY) BK BLACK
AWD CIRCUIT THIS SCHEMATIC IS FOR THE 420F2, 428F2, 430F2, 432F2, 434F2 AND 444F2 BACKHOE LOADER ELECTRICAL SYSTEM
HEATER AND AIR CONDITIONER CIRCUIT GY GRAY
TURN SIGNAL / WIPER WASHER CIRCUIT
CALLOUTS VOLUME 3 of 3: ENGINE, REAR CHASSIS AND SIDE CONSOLE
PU PURPLE
CAN DATA LINK
BR BROWN Callout Number Component
MEDIA NUMBER: UENR5149-01
OTHER COLOR DESCRIPTIONS GN GREEN (Machine Location from (52) VALVE GP - CONTROL Name
Component Locations Table)
138-1234 Part Number
HIGHWAYS BU BLUE Components are shown installed on a fully operable machine with the key and engine off, transmission shifter
in neutral and with parking brake set.
Refer to the appropriate Service Manual for Troubleshooting, Specifications and Systems Operations.
Refer to the Parts Manual using a specific serial number prefix in SIS before ordering parts from this schematic.
14 13 12 11 10 9 8 7 6 5 4 3 2 1

Sist Eléctrico 420F2

Uploaded by

Copyright:

Available Formats

Sist Eléctrico 420F2

Uploaded by

Document Information

Original Title

Copyright

Available Formats

Share this document

Share or Embed Document

Sharing Options

Did you find this document useful?

Is this content inappropriate?

Copyright:

Available Formats

Sist Eléctrico 420F2

Uploaded by

Copyright:

Available Formats

UENR5149-01

© 2018 Caterpillar, All Rights Reserved Printed in U.S.A.

Harness And Wire Electrical Schematic Symbols

Pressure Temperature Level Flow Circuit Breaker

16 CONN 16 CONN 12 Harness Identification Letters and

CONN 9 CONN 15 AG-C4 L-C12 L-C12

21 111-7898 3E-5179 3E-5179

FRONT DASH VIEW RH CAB/VALVE VIEW

15 H802-PL220 GY- 0.75

F34 20A FRONT WIPER 8 118-PL388 GY- 2.00

447-PL156 PK - 0.75 200-PL349 BK - 0.75 E543-PL214 WH- 0.75

(Dimensions: 56 inches x 35 inches)

RIGHT HAND CONSOLE T

CONN 38 Pressure Temperature Level Flow Circuit Breaker

147 Com ponent

CONN 32 148 Diode - Blocking #2

125 CONN 40 CONN 41 Port - Pow er #2

77 CONN 121 Solenoid - Implement Lockout (SS Only)

132 149 Solenoid - Pattern Changer #2 (SS Only)

131 Solenoid - Ride Control #1 B-10 91 Solenoid - AWD H-6 137

128 CONN 13 Solenoid - Side Shift (Right)

129 CONN 34 CONN 9

142 CONN 31 102 101 CONN 11 62

XK-C3 CONN 38 CABLE AS

ROLLER SIGNAL 2 D M963-RT40 BU - 0.75 CONN 20 H 452-XK16 PU- 18 1552269

E544-RT21 GN - 0.75 27 CONNECTS TO PL-C71 2 200-PV5 BK- 18 AWD CIRCUIT

PA-C4 (55) PRODUCT LINK 631 SAT

CONN 17 D 202-AT2 BK- 18 HM 450-3826 01 HEADLINER

387-6528 779-KP10 WH- 18 202-KP2 BK- 18 2 614-AC15 PU - 18 614-AC6 PU- 18

387-6593 6 5 L998-KT11 OR- 16 CONNECTS TO PL-C1 C 619-FR5 GN- 16 618-FR3 YL - 18 3 BR

(Dimensions: 48 inches x 35 inches)

434F2 and 444F2 Backhoe Loader

Harness And Wire Electrical Schematic Symbols

156 155 Component Location

221 220 Cluster - Instrument 2

226 225 325-AG135 PK-14

SS SIDE CONSOLE CP SIDE CONSOLE

178 234 235 170 171 172 158 CONN 36

AIR FILTER BLOCKED 16 420-CF79 OR- 0.75

J 124-KV2 GN - 18 C568-KV22 WH - 12 124-KV18 GN - 18 620-RF32 WH - 18 606-RF43 GY - 18 2

(7-8) SWITCH 2 T907-RJ28 GN - 18 T907-RJ30 GN - 18 H771-RJ23 BR- 16 31 E10 L740-EF12 BR - 1.00

420-RH79 OR - 0.75 133-RH52 OR - 0.75 133-RH51 OR - 0.75 A4

387-6549 202-RH89 BK - 0.75 K J878-RN20 YL - 0.75

You might also like