M22 SERVICE MANUAL

STEREO
AMPLIFIER

M22
NAD

STEREO
AMPLIFIER
 TABLE OF CONTENTS

DESCRIPTION PAGE

SERVICE CAUTION…………………………………………………………....3-4

SPECIFICATIONS………………………………………………………….... 5

WIRING DIAGRAM…………………………………………………………….....6

BLOCK DIAGRAM…………………………………………………….. ….......7-9

TROUBLE SHOOTING A GUIDE…………………......................................10

TROUBLE SHOOTING B GUIDE…………………......................................11

CIRCUIT DIAGRAMS ………………………………………………..…......12-24

PCB LAYOUT………………………………………………………………..25-30

ELECTRICAL PARTS LIST…………………………………………......31-50

EXPLODED VIEW…………………………………………………………. 51-54

EXPLODED VIEW PARTS LIST……………………………………………....55

 PRODUCT SAFETY SERVICING GUIDELINES FOR AUDIO PRODUCTS
CAUTION : DO NOT ATTEMPT TO MODIFY THIS 5. NO LEAD OR COMPONENT SHOULD TOUCH A
PRODUCT IN ANY WAY, NEVER PERFORM CUSTOM- RECIVING TUBE OR A RESISTOR RATED AT 1 WATT
IZED INSTALLATIONS WITHOUT MANUFACTURER’S OR MORE. LEAD TENSION AROUND PROTRUNING
APPROVAL. UNAUTHORIZED MODIFICATIONS WILL METAL SURFACES MUST BE AVOIDED.
NOT ONLY VOID THE WARRANTY, BUT MAY LEAD TO
6. ALL CRITICAL COMPONENTS SUCH AS FUSES,
YOUR BEING LIABLE FOR ANY RESULTING PROP-
FLAMEPROOF RESISTORS, CAPACITORS, ETC.
ERTY DAMAGE OR USER INJURY.
MUST BE REPLACED WITH EXACT FACTORY TYPES,
SERVICE WORK SHOULD BE PERFORMED ONLY DO NOT USE REPLACEMENT COMPONENTS OTHER
AFTER YOU ARE THOROUGHLY FAMILIAR WITH ALL THAN THOSE SPECIFIED OR MAKE UNRECOM-
OF THE FOLLOWING SAFETY CHECKS AND SERVIC- MENDED CIRCUIT MODIFICATIONS.
ING GUIDELINES. TO DO OTHERWISE,INCREASES
7. AFTER RE-ASSEMBLY OF THE SET ALWAYS PER-
THE RISK OF POTENTIAL HAZARDS AND INJURY TO
FORM AN A.C. LEAKAGE TEST ON ALL EXPOSED
THE USER.
METALLIC PARTS OF THE CABINET, (THE CHANNEL
WHILE SERVICING, USE AN ISOLATION TRANS- SELECTOR KNOB, ANTENNA TERMINALS. HANDLE
FORMER FOR PROTECTION FROM A.C. LINESHOCK. AND SCREWS) TO BE SURE THE SET IS SAFE TO
OPERATE WITHOUT DANGER OF ELECTRICAL
SAFETY CHECKS SHOCK. DO NOT USE A LINE ISOLATION TRANS-
AFTER THE ORIGINAL SERVICE PROBLEM HAS FORMER DURING THIS TEST USE AN A.C. VOLTME-
BEEN CORRCTED. A CHECK SHOULD BE MADE OF TER, HAVING 5000 OHMS PER VOLT OR MORE SEN-
THE FOLLOWING. SITIVITY, IN THE FOLLOWING MANNER; CONNECT A
1500 OHM 10 WATT RESISTOR, PARALLELED BY A
SUBJECT : FIRE & SHOCK HAZARD .15 MFD. 150.V A.C TYPE CAPACITOR BETWEEN A
1.BE SURE THAT ALL COMPONENTS ARE POSI- KNOWN GOOD EARTH GROUND (WATER PIPE,
TIONED IN SUCH A WAY AS TO AVOID POSSIBILITY CONDUIT,ETC.) AND THE EXPOSED METALLIC
OF ADJACENT COMPONENT SHORTS.THIS IS ESPE- PARTS, ONE AT A TIME. MEASURE THE A.C. VOLT-
CIALLY IMPORTANT ON THOSE MODULES WHICH AGE ACROSS THE COMBINATION OF 1500OHM
ARE TRANSPORTED TO AND FROM THE REPAIR RESISTOR AND .15 MFD CAPACITOR. REVERSE THE
SHOP. A.C. PLUG AND REPEAT A.C. VOLTAGE MEASURE-
2. NEVER RELEASE A REPAIR UNLESS ALL PROTEC- MENTS FOR EACH EXPOSED METALLIC PART. VOLT-
TIVE DEVICES SUCH AS INSULATORS, BARRIERS, AGE MEASURED MUST NOT EXCEED 75 VOLTS
COVERS, SHIELDS, STRAIN RELIEFS, POWER R.M.S. THIS CORRESPONDS TO 0.5 MILLIAMP A.C
SUPPLY CORDS, AND OTHER HARDWARE HAVE- ANY VALUE EXCEEDING THIS LIMIT CONSTITUTES A
BEEN REINSTALLED PER ORIGINAL DESIGN. BE POTENTIAL SHOCK HAZARD AND MUST BE COR-
SURE THAT THE SAFETY PURPOSE OF THE POLAR- RECTED IMMEDIATELY.
IZED LINE PLUG HAS NOT BEEN DEFEATED.
3. SOLDERING MUST BE INSPECTED TO DISCOVER A.C. VOLTMETER
POSSIBLE COLD SOLDER JOINTS, SOLDER
SPLASHES OR SHARP SOLDER POINTS. BE CER-
TAIN TO REMOVE ALL LOOSE FOREIGN PARTICLES.
4. CHECK FOR PHYSICAL EVIDENCE OF DAMAGE
OR DETERIORATION TO PARTS AND COMPONENTS. GOOD EARTH GROUND PLACE THIS PROBE
SUCH AS THE WATER ON EACH EXPOSED
FOR FRAYED LEADS, DAMAGED INSULATION PIPE. CONDUIT. ETC METAL PART
(INCLUDING A.C. CORD). AND REPLACE IF NECES-

SUBJECT: GRAPHIC SYMBOLS

THE LIGHTNING FLASH WITH APROWHEAD SYMBOL. WITHIN AN EQUILATERAL TRIANGLE, IS INTENDED
TO ALERT THE SERVICE PERSONNEL TO THE PRESENCE OF UNINSULATED “DANGEROUS VOLTAGE”
THAT MAY BE OF SUFFICIENT MAGNITUDE TO CONSTITUTE A RISK OF ELECTRIC SHOCK.
THE EXCLAMATION POINT WITHIN AN EQUILATERAL TRIANGLE IS INTENDED TO ALERT THE SERVICE
PERSONNEL TO THE PRESENCE OF IMPORTANT SAFETY INFORMATION IN SERVICE LITERATURE.


 SERVICING PRECAUTIONS

CAUTION: Before servicing the Stereo amplifier covered by Electrostatically Sensitive (ES) Devices
this service data and its supplements and addends, read and Some semiconductor (solid state) devices can be damaged
follow the SAFETY PRECAUTIONS. NOTE: if unforeseen easily by static electricity. Such components commonly are
circumstances create conflict between the following servicing called Electrostatically Sensitive (ES) Devices. Examples of
precautions and any of the safety precautions in this publication, typical Es devices are integrated circuits and some field effect
always follow the safety precautions. transistors and semiconductor chip components.
Remember Safety First: The following techniques should be used to help reduce the
incidence of component damage caused by static electricity.
General Servicing Precautions
1. Always unplug the Stereo amplifier AC power cord from the 1. Immediately before handing any semiconductor component
AC power source before: or semiconductor-equipped assembly, drain off any
(1) Removing or reinstalling any component, circuit board, electrostatic charge on your body by touching a known earth
module, or any other assembly. ground. Alternatively, obtain and wear a commercially
(2) Disconnecting or reconnecting any internal electrical available discharging wrist strap device, which should be
plug or other electrical connection. removed for potential shock reason prior to applying power to
(3) Connecting a test substitute in parallel with an electrolytic the unit under test.
capacitor.
Caution: A wrong part substitute or incorrect polarity 2. After removing an electrical assembly equipped with ES
installation of electrolytic capacitors may result in an devices, place the assembly on a conductive surface such as
explosion hazard. aluminum foil, to prevent electrostatic charge buildup or
exposure of the assembly.
2. Do not spray chemicals on or near this Stereo amplifier or
any of its assemblies. 3. Use only a grounded-tip soldering iron to solder or unsolder
ES devices.
3. Unless specified otherwise in this service data, clean
electrical contacts by applying an appropriate contact 4. Use only an antistatic solder removal device. Some solder
cleaning solution to the contacts with a pipe cleaner, removal devices not classified a “anti-static” can generate
cottontipped s wab, or comparable soft applicator. electrical charges sufficient to damage ES devices.
Unless specified otherwise in this service data, lubrication
of contacts is not required. 5. Do not use freonpropelled chemicals. These can generate
electrical charge sufficient to damage ES devices.
4. Do not defeat any plug/socket B+ voltage interlocks with
which instruments covered by this service manual might be 6. Do not remove a replacement ES device from its protective
equipped. package until immediately before you are ready to install it.
(Most replacement ES devices are packaged with leads
5. Do not apply AC power to this Stereo amplifier and/or any electrically shorted together by conductive foam, aluminum
of its electrical assemblies unless all solid-state device heat foil, or comparable conductive material).
sinks are correctly installed.
7. Immediately before removing the protective material from the
6. Always connect test instrument ground lead to the leads of a replacement ES device, touch the protective
appropriate ground before connecting the test instrument material to the chassis or circuit assembly into which the
positive lead. Always remove the test instrument ground lead device will be installed.
last.
Caution: Be sure no power is applied to the chassis or circuit,
Insulation Checking Procedure and observe all other safety precautions.
Disconnect the attachment plug from the AC outlet and turn the
power on. Connect an insulation resistance meter (500V) to the 8.Minimize bodily motions when handing unpackaged
blades of the attachment plug. The insulation resistance replacement ES devices. (Normally harmless motion such as
between each blade of the attachment plug and accessible the brushing together of your clothes fabric or the lifting of
conductive parts (Note 1) should be more than 1 M-ohm. your foot from a carpeted floor can generate static electricity
Note 1: Accessible Conductive Parts including Metal panels, sufficient to damage an ES device.)
Input terminals, Earphone jacks, etc.


 SPECIFICATIONS

OVERALL SPECIFICATIONS
Continuous output power into 8 ohms and 4 ohms ≥ 250 W (ref. rated THD, 20 Hz – 20 kHz, both channels driven)
Rated THD (250 mW to rated power, CCIF IMD, DIM 100) ≤0.005 % (ref. 20 Hz - 20 kHz)
IHF dynamic power 8 ohms : 355 W
4 ohms :640 W
2 ohms : 620 W
FRANÇAIS

Damping factor >800 (ref. 8 ohms, 50 Hz and 1 kHz)

Input sensitivity 1.6 V (ref. rated power)
Signal-to-noise ratio, A- weighted > 98 dB (ref. 1W)
Signal-to-noise ratio, A- weighted > 120 dB (ref. rated power)
Frequency response ± 0.1 dB (ref. 20 Hz - 20 kHz)
- 2.5 dB at 3 Hz and 100 kHz
ESPAÑOL

Time to go to Standby mode at no input signal ≤ 30 minutes

POWER CONSUMPTION
Rated power 640 W (120V 60Hz, 230V 50Hz)
Standby power < 0.5 W
Idle power < 40 W
ITALIANO

DIMENSION AND WEIGHT

Unit dimensions (W x H x D) * 435 x 103 x 379 mm
17 1/8 x 4 1/16 x 14 15/16 inches
Shipping weight 15.0 kg (33.1 lbs)

* - Gross dimension include feet, front panel and rear panel extensions (knobs, buttons, speaker terminals, sub fascia, etc.)

NAD SHALL NOT BE HELD LIABLE FOR ANY TECHNICAL OR USER INTERFACE DISCREPANCIES IN THIS MANUAL. THE M22 SERVICE MANUAL MAY BE SUBJECT TO CHANGE
DEUTSCH

WITHOUT PRIOR NOTICE. CHECK OUT WWW.NADELECTRONICS.COM FOR THE LATEST VERSION OF THE M22 SERVICE MANUAL.
NEDERLANDS
SVENSKA
РУССКИЙ

5
6
 Block diagram
unbalanced
OP CM R DC servo OP Hypex

Analog Input
LM E49720 TL072 TL072 LM E49720
Relay NC400 OEM M odule
balanced

Clipping controler

OPA2134

LED

IIC
TOUCH

CY8CM BR2044

M icro controller
TRIGGER
IIC/SPI/GPIO
PIC18F26K20

3.5mm

Audio sense on/off

STB

5V 3V3
100-120V A C LDO
STB PSU
220-240V A C Currentsensor

ENABLE TL084CN

+/-14.5V
AC
M AIN PSU

+/-VB
+/-VDR

7
Regulated supply +/-17.5V Regulated supply
+/-VAUX
LM 317/LM 337 LM 317/LM 337

7
PIC18F26K20
MCU BOARD
Data Bus<8>
Table Pointer<21>

8 8 Data Latch PORTA

inc/dec logic RA0/AN0
Data Memory RA1/AN1
PCLATU PCLATH RA2/AN2/VREF-/CVREF
21
RA3/AN3/VREF+
20 Address Latch RA4/T0CKI/C1OUT
PCU PCH PCL
RA5/AN4/SS/HLVDIN/C2OUT
Program Counter 12 OSC2/CLKOUT(3)/RA6
Data Address<12> OSC1/CLKIN(3)/RA7
31-Level Stack
Address Latch 4 12 4
BSR FSR0 Access
Program Memory STKPTR Bank
(8/16/32/64 Kbytes) FSR1
FSR2 12
Data Latch
PORTB
RB0/INT0/FLT0/AN12
inc/dec
8 logic RB1/INT1/AN10
Table Latch RB2/INT2/AN8
RB3/AN9/CCP2(1)
RB4/KBI0/AN11
ROM Latch Address
RB5/KBI1/PGM
Instruction Bus <16> Decode
RB6/KBI2/PGC
RB7/KBI3/PGD
IR

8
Instruction State machine
Decode and control signals
Control
PRODH PRODL
PORTC
8 x 8 Multiply RC0/T1OSO/T13CKI
3 8 RC1/T1OSI/CCP2(1)
RC2/CCP1
BITOP W RC3/SCK/SCL
8 8 8
RC4/SDI/SDA
Internal RC5/SDO
OSC1(3) Power-up RC6/TX/CK
Oscillator 8 8
Block Timer RC7/RX/DT
(3) Oscillator
OSC2 ALU<8>
LFINTOSC Start-up Timer
T1OSI Oscillator Power-on 8
Reset
16 MHz
T1OSO Oscillator Watchdog
Timer
Precision FVR
Single-Supply Brown-out Band Gap
MCLR(2) PORTE
Programming Reset Reference
In-Circuit Fail-Safe
VDD, VSS Debugger Clock Monitor
MCLR/VPP/RE3(2)

BOR Data
EEPROM Timer0 Timer1 Timer2 Timer3
HLVD

FVR
ADC FVR
CVREF Comparator ECCP1 CCP2 MSSP EUSART 10-bit

Note 1: CCP2 is multiplexed with RC1 when Configuration bit CCP2MX is set, or RB3 when CCP2MX is not set.
2: RE3 is only available when MCLR functionality is disabled.
3: OSC1/CLKIN and OSC2/CLKOUT are only available in select oscillator modes and when these pins are not being used as digital I/O.
Refer to Section 2.0 “Oscillator Module (With Fail-Safe Clock Monitor)” for additional information.

8
TNY274
SMPS STB BOARD

BYPASS/
MULTI-FUNCTION DRAIN
(BP/M) (D)
REGULATOR
5.85 V

LINE UNDER-VOLTAGE
115 μA 25 μA
FAULT BYPASS PIN
PRESENT UNDER-VOLTAGE
+
AUTO- BYPASS
RESTART CAPACITOR
-
COUNTER SELECT AND
5.85 V VI
CURRENT
4.9 V LIMIT
6.4 V RESET LIMIT STATE
MACHINE
CURRENT LIMIT
COMPARATOR
ENABLE -

JITTER
CLOCK
1.0 V + VT
DC MAX THERMAL
SHUTDOWN

OSCILLATOR

ENABLE/ S Q
1.0 V
UNDER-
VOLTAGE
(EN/UV) R Q

LEADING
OVP EDGE
LATCH BLANKING

SOURCE
(S)

9
 TROUBLESHOOTING A GUIDE

No Pow er or Pow er shuts off

immediately

NO Check STB board NO check IC301 circuit

Logo Amber LED on?
5V RIGHT? change STB board

YES
YES

Check LED board NO

Touch Pow er key Check L104 C175 C176
5VL RIGHT?

YES

YES
Check Q110 Q111 Q114 Q115 Q116 circuit
Check PWM signal
Change LED board

NO NO Logo led turn off?

Logo led turn w hite? Logo led turn red?

YES YES

YES

Check PSU board NO Check STB board NO Check MCU board:Q131 circuit
+/-VB +/-VAUX +/-VDR RIGHT? STB 3V RIGHT? Check STB Board:Q301 K301 circuit

YES

Check U1 U5 PWM circuit

YES Change PSU Board

Check MCU Board NO Check Q123 Q124 circuit

VPP VPI +/-17.5V +/-VDR RIGHT? Change MCU Board
Check MCU Board

YES

Check U104,
Check LED control signal
Change MCU board

10
 TROUBLESHOOTING B GUIDE

NO Rear panel led show red? NO led turn off?

Rear panel led show green?

YES YES
YES

Check Q500 Q502 Q508 circuit

Check D500 U505 circuit,
Change NC400 OEM BOARD

Apply 1khz sinew ave to DUT

NO NO NO checkQ505 Q506 Circuit

Amplifier output correct? INC INH signal correct? check+/-14.5V,5V Right?
change AMP board

YES YES YES

checkU500 U501 U502 U503 Circuit

Change NC400 OEM BOARD checkQ503 Q504 Circuit
change AMP board

F i n i sh

11
 CIRCUIT DIAGRAM

1.MCU VM1.0

0.22u/ 16v
R100
C100 R101
1K 100K 5VA XM102 XM101
47K R111 HOLE HOLE
AudioS
5VA 2 5 D101 R112 R113 5VA R114

R115
1 7

15K
5K6 5K6 10R 5VS D140 D135

100K
3 6

R117
R116 ISS352 ISS352
U100A U100B ISS352
100K Q104 C103 D139 D137
LM324 LM324
2SA1312 10U ISS352 ISS352
U100D 5VA 100R
GND 10 LM324 D104 R291 R283 100R
C163 22N

4
U100C 8 GND
GND GND

1
12 LM324 9 C104 R122
R124

1 2
R127

R125
5K1

100K
14 ISS352 100N C166

15K
U100E 100R
C105 13 22N
R129 LM324

11

2
10U
100K GND
GND
GND GND
AUDIO SENSE
XM104
XM100
HOLE
HOLE
VPP
D146
ISS352
D134

100R

2.5mR
2N2 D147
9 R139 ISS352

R144
C107 ISS352
8 3 R141 D136
GND 100R
U102D 10 1 ISS352 R293
100R

4
TL084 2 R282
Q113 C162 100R GND
GND U102A GND 22N
BCV62B GND C168
i d l i n g 0 V U102C R151 TL084
R152 R153 22N
TP1 12 1
R136 10K 330K 330K 1 VPPi
VCLIP0 14
200R TL084 470N JP100

R16 0
13 2

47K
R137 C112 2

1
VCLIP1 R163 U102B D110 3
200R R164 Q117 3 VPPi
R167 TL084 5 D109
12K 47K 15V

3
7 2SA1312 ISS352
10K C113 VPNi
6 Q118 XM103
R171 2

1 3
+17.5V 2 10U/35V JP101 HOLE
C11510K 2SC3324

22K
C114 R173
06- 10021- 06 VPNi
R176
1K D111 1U 10n
C116
4

1
2N2 D141
GND
U102E CON106 ISS352
GND GND JP102

R325

R175
TL084 ISS352 D142

33K

5K1

22K
7K5

1
2
3
4
5
6
7
8
R180
GND R179 ISS352
C117 GND
11

2N2 100R
D159 R292

PWM -L ED
R319

W /R-L ED
-17.5V D160 4v7 GND
-17.5V 1K5 GND CLIPPING CONTROL R309

A -L ED
4v7 POWER_ON 5VS C167
P100 TO AMP board A 10K
22N
GND 36 35 GND
-17.5V +17.5V
34 33 D158 3V3D
32 31 4v7 GND
C101
30 29 C102
10N
28 27
A MP M ODUL E1

10N
VPPi 26 25 VPPi GND P103
24 23
GND GND 10
VPNi 22 21 PS_EN
9
20 19 VPNi
8
18 17 VAUX+
R119 7
16 15 0R VDR- VAUX-
R120 FB100 6
GND 14 13 0R VDR+
5 R323 Q124
12 11 -17.5V nFATAL 8 1 VAUX+ +17.5V
4 0.47
5V S 10 9 +17.5V OVL 7 2
R121 3

3
8 7 GND D118 nAMPON 6 3 C177 R185

R341

R349
0R

3K 9
G POb0 SCL GND 2

10K
R332
R130 R123

22k
220U

220U

100N
6 5 3V6 AMPOFF 5 4 1 2 10U

10K
C131

C128
0R 0R

C122
G PI0 R131 R126 SDA 1 C124

220U
4 3 C182

C126
0R 0R C125 A1220
R128 GPOa0 D168 100N
2 1 0R 100N 100M/600R FROM PSU BAV99 D170 1U
R201 D162 16V
GND 1k 15V
22k
GND GND C178 GND VAUXa
VAUXa R333 D166
Q121 47P
VCLIP0 P112

R 202
R133 CD4148WP
0R D119 C183 BC846B
R135 AudioS GND

0R
0R 3V6 5VS 1 10U R348 R338
C133 R186 GND 2 GND 680 680
STB_EN HS1
D107 D106 D105 100N 100 3
R208 Q122
GND 10k

R336

R339
3V 3S

680
4V7 4V7 4V7 FROM STB BC846B

470
R210 H eat si n k
VHP1 180k R203
P105
VHP1 180k

R 331

R 330
VDR+ 1

10K

10K
C137 MCLR U105
GND GND GND GND VPP 2 GND
NC R324
3 Q123
R216 1 28 PG D A TA D TA 114 VAUX- -17.5V
3V3S 22k MCLR/VPP/RE3 RB7/KBI3/PGD VDR- 4 0.47
3V3D 2 27 PG CLK Q 131
RA0/AN0/C12IN0- RB6//KBI2/PGC VPNi 5

3
GPOa0 R209A U104 C136 3 26 R223 STBY DTC114EKA VPPi
100R RA1/AN1/C12IN1- RB5/KBI1/PGM 100R 6

c
GPOb0 R209B 1 16 4 25 Q105 2 1 C184

R334
N CK0 R219 R220

22k

3K 9
100N

220U

220U
q1 vcc GND RA2 RB4/KBI0

C123

C127

R342
100R 100R 100R

C132
1

220U

100N
C130
GPOa1 R209C 2 15 N M OS I R222 5 24 A udioSa D154 GND From PSU C181 10U

C129
100R q2 q0 100R RA3 RB3/AN9 C2690
P101 TO AMP board A GPOb1 R209D 3 14 100N NCS1 R225 6 23 R229 b BAV99 D163 BAV99 1U
100R q3 ser 100R RA4 RB2/INT2 100R RT1 D169
R213A 4 13 R214 GPI0 R228 7 22 R232 OVL 3
GND 36 35 GND 100R q4 /g 10K GND 100R RA5/HLVDIN RB1/INT1 100R Rt NTC 22k 16V
R213B 5 12 8 21 R233 nA M PO N GND C179 GND
34 33 100R q5 rck GND VSS RB0/INT0/FLT0/AN12 100R R335
A-LED R213C 6 11 GPI1 R231 9 20 BC856B 47P
32 31 100R q6 sck 100R OSC1/CLKIN/RA7 VDD 3V3S BC856B

e
-17.5V+17.5V W/R-LED R213D 7 10 10 19 D 123 C180 Q126 D167
30 29 100R q7 /sclr 3V3D OSC2/CLKOUT/RA6 VSS GND GND Q125 CD4148WP

2
8 9 C140 11 18 RXD 4V 7 Q120 10U
28 27 gnd q'h 100R RC0 RC7/RX/DT R347 R340
C109 100N 12 17 TXD C 143 GND FMMT593TA GND
VPPi 26 25 VPPi R226 RC1 RC6/TX/CK 680 680
10N C108 GND 74HC595 13 16
A MP M ODUL E2

100N
24 23 10N RC2 RC5/SDO C173 D155 R346
SCL 3V3S R240 14 15
22 21 RC3/SCK/SCL RC4/SDI/SDA R327 3V6

R337
0R R235 100N

680
470
VPNi 20 19 VPNi 120K
GND GND 100R
18 17
R158 SDA R244 PIC18F26K20
16 15 VDR-

R326

R328

R329
120K
0R 0R

4K3

10K
R161
GND 14 13 0R VDR+
GND
12 11 -17.5V
R245 PWM-LED
5VS 10 9 +17.5V
R107

R108

R297

R296

100R
10k
10k
10K

10K

R165
8 7 3K9 GND
GND
TRI GON_OFF

GPOb1 R172 R168 SCL

0R 6 5 0R
GPI1 R174 R169 SDA
0R 4 3 0R
R170 GPOa1
TRI GI N

2 1 0R
3V3D 3V3D 5VS
D124 C147
L101 Q132 L102
3V3D 3V3S 3V3S GND 3V3S
VCLIP1 742792662 CON103
D

R177
S

0R 742792662
22u/ 6v3

AudioS MCLR
C174

R178 ss12 100N

0R 1

3
3V3S
G

2
APM2313 GND 3

IN
OU T
D114 D113 D112 GND R239 R241 PGDATA
4
22u/ 6v3

4V7 4V7 4V7 10K 10k PGCLK

C138

C139
C156 5
100N C155
ICSP

O
100n 470U/6V3

22u/6V3
C158
100n
C152 L103
C151 10n
GND 3V3S

4
GND GND GND GND C159 FB
5VEN 3V3SU108 100n P109
Q135
C146 ASM1117- 3.3
DTC114EK A GND 4
TXD R268
1N 100R 3
RXD R269
trig n
i 100R 2
1 1 C164 GND
J101A 17- 02001-
5
55 R284
P110 P111 GND
GND 1
470R 232 gnd PB1 PB2 GND 3V3S
4 D EBU G Header 4
1 1 R285
3 100n
10KJ 2 2 47KJ
2 U109 R286
R287 3 3
1 C165 D138 3 4 TRI GON_OFF
4 4 a2 y2 120R
R288 2 5
6k8

gnd vcc R289

SW1 100N 4v7 TO MAIN TO MAIN 1 6 TRI GIN
a1 y1 120R
2 1 R290
GND
SW(TOUCH) NC7WZ17
232 gnd 10R
Whi t e l ed br i ght ness ADJ

12
2.AMP VM1.0

+14.5V

D516

6K8
Q508

A R500
c e

33K
R502
10K c e +14.5V
R590
1SS352
D500
Over cur re nt in di cat i on

b
GREEN RED

b
D502
c e
10K c e +14.5V
c K1

K2

R503
1SS352 DTA114
Q502
Q500

b
Q501 DTC114EKA
R504
DTC114EKA b D503
10K

b
1K DTA114
R505
1SS352
e

17- 01001- 12 GND GND INC

J500 2
R506 R507
RCA 2 3 1 3
100R 12K 4K75
T500 3 1 R508 R588
4K75 47K R509 10R VCL+
2 2 P500 VPP
R511
47K

C558 RL500A R510 C567

100P U500A 1 VPP VPP

4K64
R513
R512 VPP 1 2
1 4 LME49720 3 GND GND GND GND
10K 220K 3 4
I NPUT L504

47K
R517

R594
C501 R514 U501A 1U/ 25V GND GND
2K43 10K R515 GND 5 6

R521
1K2
VPN

10K
220P R518 C502 LME49720 GND GND
100R

7 8
R586

C569 R520 10K C503 R519

3
J502 C504 1U NC +14.5V VPN VPN

8
100n 10U/16V 6 VDR- 9 10 VPN
R522 100N VDR NC 22- 01626- 00

500R
845R

392R

470K
2 7 VDR+ 11 12
R516

R523

R524
220K

2 U501C

R525

R526
C500 1 4 GND GND TL072 GND TL072 GND L505 OUTC OUTC OUTC CN501
1 C505 5 LME49720 13 14 1
100P 100R C506 U502B OUTC OUTC C507 SP-
3 10U/16V R583 15 16
T501 GND U502A 100N C508 NC -14.5V C553 GND FBC OUTC 10N 200V

4
GND 17 18 GND

1
R529
C568 10N 200v C510 C511

C570

10K
XLR3F C509 1U U501B FBH OUTH

1n8
2K43 R528 19 20
2 3 5 GND C554 10U/ 25V CN502
47K
R531

C512 220P R527 LME49720 OUTH OUTH 10N 200V

4K64
R532
21 22 1
220K

10K 220K
7 1U/ 25V 10N 200vGNDGND OUTH SP+
R530

100P U500B OUTH OUTH

R533 23 24
GND 6 LME49720 6 R589 VSN VSP
R534 R535 10R VCL- -14.5V 25 26 +14.5V
6 7 GND NC
R536 4K75 47K R537 GND 27 28
4 5 INH INH INC C513
100R 12K 4K75 29 30
5 OPT nAMPON 10U/ 25V
R538 31 32
R587 RL500B CLIP SCPIND
10K 33 34
R539 SDA/RDY SCL/nFAL GND
4.7 MEG R540 R595 35 36
+14.5V TP2 4K12 1K
GND R541 AMP MODULE
C516 C515 C514 10U/ 10V
10R +14.5V

8
100nZ 100nZ 100U/ 25V C556
GND
5V U503A
GND GND
5V OPA2134 3 bi as D518
R542 4v7
C517 1 C518 XM500 XM501
C520 C519 VCL + m2 2 6 .2 v 5k C557 47U/ 25V
8

4
100U/ 25V 2 HOLE HOLE
100nZ 100nZ m2 7 6 .5 v 100nZ

8
10R
R543

C521 U504C -14.5V

U500C U502C D519 OPA2134 D515 P502
1U MCP6002 R544 R545 R593 GND GND
LME49720 TL072 4v7 U503C NC
10K2 4K7 GNDC 35 36 GNDC
4

13K
C522 33 34

4
GND
10K2 10K2 C523 47U/ 25V R565 31 32
C524 R546 U504B
R547 R548 R549 100nZ GND NC 29 30
5 MCP600 2
C525 2.2MEG 680K 27 28
7 6 GND
220U/10V R551 25 26 VPPi D504 D506
5V 10n 6 7

R585
VCL - 10R -14.5V VPPi 23 24 1SS352 1SS352
2 C526 R552 5
R553

0R
GND 21 22 D505 D507
GND 1
10K 330K VPNi 19 20 VPNi 1SS352 1SS352
2

Q503 Q504 3 U503B

U504A 17 18 R554 R555
Source S500 2SA1015 2SA1015 1U OPA2134 100R 100R
SET
R556 R557 MCP6002 VDR- 15 16 GNDC
BAL SE 7 8 C529 R558 +17.5V-17.5V C527
10K 10K R559 R560 VDR+ 13 14 GND C528
22N GND
2.2MEG 680K 100k 5V 11 12 22N
1

L507
RESET
C530 R562
RL500C 9 10 5VS
10n 10U IIC add L506 XM502 XM503
R564 GND 100k GND 7 8 R566
C531 Q505 SCL R561 GPO1 HOLE HOLE
6K8 0R 5 6 NC
10U 2SC1815 SDA R563 GPI
Q506 0R 3 4 NC
GPO0
2SC1815 1 2 R567
A DJ
22K
R568

R569
47K

GND GND TO Mother board

R570
3 2 C555 VCLIP
GND +17.5V 3R3 IN OUT +14.5V R550 0R
U505 AudioS
R572 5K6 0R
LM317M
R571
1

R576 10U/ 25V D508 D510

22K
R573

R574
47K

309R
C532 1SS352 1SS352
R575
10U C533 R577 L501 D509 D511
6K8 3K24 VPPi VPP
C534 100U/ 25V 100nZ 744302015 1SS352 1SS352
C538 C539 C540 C541 C542 R578 R579
L502 JP500 100R 100R
10U/ 25V 100nZ 10U/ 25V 10N 250V C535 C559 C560 C561 330n/ 200V
5VS 5V
100U/ 100V100U/ 100V100U/ 100V100U/ 100V C536 C537
GND GNDC GND GND GND
BMB2A0600RS2 COPPER BAR 22N 22N
C547 C548 C543 C544 C571 C549 C550
10U/ 25V 100nZ 10U/ 25V 10U/ 10V 10U/ 10V 10N 250V C546 C562 C563 C564 330n/ 200V
744302015
C551 C552 R580 100U/ 100V
100U/ 100V100U/ 100V100U/ 100V XM533 XM534
3K24 VPNi VPN
100U/ 25V GND GND GND L503 HOLE HOLE
100nZ
10U/ 10V
316R
R581 C545
1

U506
2 LM337M
-17.5V 3R3 IN OUT -14.5V
3
R582
A DJ

D501 D512
1SS352 1SS352
D513 D514
1SS352 1SS352
R501 R584
100R 100R
C565 C566
GND GND
22N 22N

13
3.NC400 OEM VM1.0(1/4)

J3 Mechanical Mechanical Mechanical

SDA/READY SCL/nFATAL Bare PCB SILPAD_TO220 TO126 Spacer 3.5x6x7.3mm ALU Hansong
D29 35 36
CLIP SCCPIND Mechanical
33 34
A1/OPTION A0/nAMPON Mechanical Mechanical Spacer ALU 3.5
BAS316 31 32 Spacer 3.5x6.3x5mm ALU Hansong
IN B + IN B - Assembly SILPAD_TO220
29 30
IOUT Mechanical Mechanical
GND 27 28 Spacer 3.5x6x4.5mm ALU Hansong
+VB Spacer ALU 3.5 Spacer ALU
-Vop 25 26 +Vop
Mechanical
R1 23 24
OUTH C1 Mechanical Mechanical Spacer ALU 3.5
21 22
FBH OUTH 100n Screw insulator M3 Spacer ALU 3.5
4R7 19 20 GND
FBC C2
17 18
OUTC 100n Mechanical Mechanical Mechanical
C3 15 16 -VB
OUTC C4 Screw insulator M3 Spacer ALU 3.5 Spacer ALU
13 14
100n
4n7 VDR_EXT 11 12 VDR_EXT
-VB 9 10 -VB
7 8
Mechanical Mechanical
GND 5 6 GND
M3 M3
3 4
+VB 1 2 +VB
Mechanical Mechanical
CON_2x18MH M3 M3

Mechanical Mechanical Mechanical Mechanical

M3 M3 Hsink SAA6L8W0H2T1 Hsink SGG8L6W2H0T1

Mechanical
M3 Mechanical Mechanical Mechanical
M3 M3 M3x16
Modulator Power Stage
Mechanical Mechanical Mechanical
INB+ M3 M3 M3x16
INH
INB- OUTH
INC PSRR+ +ISENSE+ OUTH
+ISENSE- OUTC
OUTC Mechanical Mechanical Mechanical
FBH M3 M3 M3x16
FBH -ISENSE+
FBC
FBC PSRR- -ISENSE-
FBLH
GND Mechanical Mechanical
M3 M3x16
FBLC
CTRLH CTRLH FBLH

LSENSE+
LSENSE-
CTRLC CTRLL FBLC
Mechanical Mechanical
ENABLE SCCP
M3x16 M3x16
CLIPPOS VSW
CLIPNEG
Mechanical Mechanical
M3x16 M3x16

Mechanical Mechanical
M3x16 M3x16

Control Mechanical
M3x16

ENABLE +HVPS
CLIPPOS +ISENSE
CLIPNEG -ISENSE
A1/OPTION
A1/OPTION -HVPS
A0/nAMPON
A0/nAMPON
SCL/nFATAL J1 J2
SCL/nFATAL
SDA/READY
SDA/READY SCCP 1 1
SCCPIND
SCCPIND VOUT
GND Mounting Hole GND Mounting Hole
VDR_EXT VDR_EXT VSW
CLIP
CLIPIND
J4 J5
IOUT
IOUT LSENSE+ 1 1
LSENSE-
GND Mounting Hole GND Mounting Hole

NC400OEM V0.1 - Sheet 4 - uP.SchDoc

1
3.NC400 OEM VM1.0(2/4)

C76 C5 C6 C7 C8 C9
100n 100n 100n 100n 100n 100n
R144 R2 R3 R4 R5 R6
1R 1R 1R 1R 1R 1R
L1
+PS
+VB +ISENSE+
C10 C11 C12 C13 C14
1u/8A
R7 R8 100u R9 100u 100u 100u 100u
C15 1R 33k 2.5m
22u
D1
1 2 GND GND GND GND GND
C16 +ISENSE-
D2

1
C18 L2 R15:NC
GND 100n R10 R11 BAV99W

3
C17 C18
BAV99W 10k 470R 3
R12
GND T1
15p 150p L2 LSENSE+
BC817W J8
D3

1
220R C19 R13 T2 33n
D4 T3A R14

2
1
3 BAV70W MBT3906 10R
BAS316 470n 2R2
D5 GND Mounting Hole
FDP42AN15 R15

T4 C20

2
2V4 12R 100p LSENSE-
BC807W R16 VDR
100k GND
FBLH
T3B GND
T5 C21
D6 R17 MBT3906 R18 R19 R20 R21
CTRLH C22
220u 1k L3 33k 1R 1R 1R
15V
470n V SW 10u OU T
OUTH
BF622
C23

VDR
T1T6:fmmt618;T4T11fmmt718 GND
R22 C24 4n7
R23
C25
680n
C26
680n
C27
680n
6R8 330p GND OUTC
D7 GND
R24 L4 R25
1 2 4R7 R26 R27 R28
D8
0.5W VSW
1R 1R 1R

1
2R2 600R/0.2A 1M
D9 R29 R30 R31 BAV99W

3
1

C28 C29 FBLC

BAW56W 10k BAV99W 10k 470R 3 T6 BC817W GND
D10 R32
3 T7
18p 150p L5
BC856BW

1
D11 220R C30 R33 33n
5V6 D12 T9A T8

2
C29 L5 R35 :NC
T10 3 BAV70W MBT3906
2

CTRLL BAS316 470n 2R2

R34 D13 FDP42AN15 R35
T9B T11 BC807W

2
1k BC846BW 12R
MBT3906 2V4 R36 J9
100k
1

R38
MMBT5401
GND
C31 C32 R37 T2,T8:FDP52N20 GND Mounting Hole
T12 T13 470n 470n 1k
SCCP
BC846BW
1k C33 -ISENSE+
GND GND GND GND GND GND
100n
R40 R39 D14 R41 R42
GND 2k2 1k C34 1R C35 C36 2.5m C37 C38 C39 C40
5V6 L6
470n 22u 100u -PS 100u 100u 100u 100u
-ISENSE-
1u/8A
-VB C41 C42 C43 C44 C45
100n 100n 100n 100n 100n
R43 R44 R45 R46 R47
1R 1R 1R 1R 1R

GND GND GND GND GND

1
3.NC400 OEM VM1.0(3/4)

+Vop

R48
220R
T14A
R49 T14B BC856S
FBH FBLH
BC856S
820R
R50 R51
R52 3k 100k

PSRR+

PSRR-
10k R53 R54 R55
C46 6k8 6k8 1k
R56 560p
C47 C48 2k7 GND
1n8 1n8
R57 R58 R59 R60
R61 R62
INC
360k 360k T15A
1k2 1k2 47k 1k5
BCM856S
R63 T20A
+Vop BCM856S
1k5
U1A
V+ NE5532

8
3 GND GND VDR
R64 R65 1
47R 1k8 2
R66 R67 R68 R69 R70
V- T15B R71 47k 2k7 2k7 560R 10k C49
4

C50 BCM856S 47k C51 100n

2n2 R72 T20B 100n
-Vop
R73
BCM856S T17B
1k5 CTRLH
BC856S
R74 R75 R76 R77 560R
R78 R79
INH T16A T16B
360k 360k T17A
1k2 1k2 47k 1k5 CTRLC
J10 BC856S BC856S BC856S
Jumper R80
2k7 T19B
C52 C53 R81 R82 T18B
BC846S
R84 1n8 1n8 C54 GND R83 BC846S
560p 270R 270R
10k R85 -Vop 560R
GND 3k T19A T18A
BC846S BC846S
R86
FBC FBLC
820R
R87 R88 R89 R90
MMST5401 1k 1k 560R T21
BC846BW
120R

BC856BW
R91 T23 T22 R92
+Vop
ENABLE
BC846BW
4k7 R93 R94
R95
T24 R96 R97 R103 4k7
C67 47R 82R 200R
BCV62B 10k 22k 1k
1n GND
-VB
D15
D16 BAS316 R98 T25
3V3
10k BC856BW
T26
CLIPPOS
BC846BW
R99
GND
100R
T28
CLIPNEG
BC856BW
R101 T29
D18
BC846BW
3V3 10k
D19
BAS316
T30
BCV61B R102 R100 R128
10k C75 22k 1k
1n

-Vop

1
3.NC400 OEM VM1.0(4/4)

R104
NC
10M
R105 C55 C56
LSENSE+ GND
2k4 10u 1n5
U1B
NE5532
+Vop 5
7
6
R106
330R
R107 C57 C58
LSENSE- IOUT
R111 NC 2k4 10u 1n5
R109 R108
330R 10M

+HVPS R110
R111 2k2
390R C59 J11 Reset
R112 10n T31
+ISENSE BC846BW 1
82R 2

Not placed
T32 3 CLIPIND

SCCPIND
D20 4
BCV62B 3V9 T38
C60 C61 C62 5 BC846BW
2u2 2u2 2u2 CON_1x5MV
D21 D22
12V BAS316 GND
3VPIC
R113 T33 GND
MMBT5401
150k T34 +VB
R114 BC846BW
10k C63 U2
R115 R116 R127 R117 R118 R151 R119 R120 2u2 R121 R133 R122 R123 R124
1k 27k 10k 10k 10k 12k 8k2 2k2 GND
20
Vss
V ss VDD
V DD
1 1k 390k 1k8 27k 27k
R125
10k GND 19
RA0/AN0/C1IN+/ICSPDAT/ULPWU
RA0/AN0/ C1IN+/I CSPDAT/ U LP WU RA5/T1CKI/OSC1/CLKIN
RA5/T1 CKI/ OSC1/CLKIN
2

18 3
GND RA1/AN1/C12IN0-/VREF/ICSPCLK
RA1/AN1/ C12IN0-/ V REF/I CSPCLK RA4/AN3/T1G/OSC2/CLKOUT
RA4/AN3/T1 G/OSC2/CLK OU T
17 4
R126 SCCP RA2/AN2/T0CKI/INT/C1OUT
RA2/AN2/T0 CKI/INT/ C1OU T RA3/MCLR/VPP
RA3/M CLR/ V PP A0/nAMPON
10k CLIPPOS 16
RC0/AN4/C2IN+
RC0/AN4/ C2IN + RC5/CCP1/P1A
RC5/CCP1/P1A
5
ENABLE
15 6
R129 CLIPNEG RC1/AN5/C12IN-
RC1/AN5/ C12IN - T/P1 B
RC4/C2OUT/P1B
RC4/C2OU
10k R130 14 7
-VB RC2/AN6/C12IN2-/P1D
RC2/AN6 /C12IN2- /P1D RC3/AN7/C12IN3-/P1C
RC3 /AN7 /C12IN3- /P1C A1/OPTION
R131 T35 390k C64 13 8
MMBT5551 10n SDA/READY RB4/AN10/SDI/SDA A
RB4/AN10/SDI/SD RC6/AN8/SSS
RC6/AN8/S
R132
150k 12 9 R140 C66 10k C65
D23 D24 RB5/AN11/RX/DT
RB5 /AN11 /RX /DT RC7/AN9/SDO
RC7/AN9 /SDO 10n 100p
12V BAS316 GND 10k
T36 11 10
SCL/nFATAL RB6/SCK/SCL RB7/TX/CK

R134 BC846BW PIC16F690

T37 VOUT VOUT
R135 BCV61B 1M
-ISENSE R136
82R R137 VSW
4k7
330R C68
10n R138
-HVPS R139 R145 R141 R142 R143 3VPIC 100k
27k 12k C69 10k 1k2 1k8 C70 C71
1u 100p 100p
+Vop
R137 NC GND

R152
10k D28 GND
T42
GND BC846BW
10V R153 -VB
10k

D25 R146 R147 R148 GND

VDR_EXT 47k 47k 68R +Vop
BAS316 T40 C72
D26
BD139 22u
T39 BAS316 GND
BCP56 R149 T41 C73
VDR BC846BW 22u
18k
-Vop
J12 C74 R150
470n D27
1 13k 5V6
GND Mounting
Hole

-VB

17
.LED&TRIGGER&TOUCH VM1.0

5V L

D 102 W H IT E
D 156 W H IT E
D 157 W H IT E
Q 114

2 2 0R

2 2 0R

2 2 0R

2 2 0R
D T A 114 C175

R320

R322

R321
R104

R347

R348

R312

750

750

750
5V L
100N

5V L

CO N 107
C176
Q 115

D 103
2U2

1
AMBER
D T C114 E KA
D GN D L 104
3V 3D
FB
PW M -L ED

4K7
R103
5V S 8
Q 10 9 3V 3D 7
W/R-L E D

4K7
R102
D T C114 E KA 6

2
A -L ED
5

D 163

D 164

D 150
RE D

RE D

RE D
4
D GN D PWM -L ED
3
Q 112
W/R-L E D 2
Q 111 D T C114 E KA
1
D T C114 E KA
Q 110
D GN D D GN D 5V S CO N 108
D T C114 E KA
Q 116 A -L ED D GN D 4
D T C114 E KA L ED I n d i c a t o r 3
t ouc h on
2
D GN D 1

D GN D
D GN D

LED

V CC
CO N 10 1
L 100
4
FB 3
C17 4 C110 G PO
2
2 .2 N F 10 U FB
GN D 1
L 105
GN D
GN D
C111
10 0 N

15
16

14
13
trig in U 101
17 - 0 2 0 0 1-5 5 R2 8 4
1 1
J 10 1A 5 P1 10

G PO 2

G PO 3
CM O D

VDD
R118
10K
470R 232 gnd PB 1 PB 2
4
1
3
10KJ 2 1 12
2 G PO 1 SCA N R/SL EEP GN D
R2 8 7 3 G PO 2 11
1 C165 D 13 8 G PO 0 X RES
4 3 10
T O G G L E / FS S
6k 8

R2 8 8 CS3
4 9
SW 1 100N 4 v7 T O M A IN D EL A Y A RST
2 1

V SS
SW (T O U CH )

C S0
C S1

C S2
Wh i t e l e d b r i g h t n e s s A DJ 232 gnd

R154

R311
R318

0
R132

5
6
7
8
0
0
GN D GN D GN D
GN D GN D
C Y 8CM B R 2 0 4 4

R155
56 0
CS0
Trigger
TOUCH

1
5.SMPS VM1.0(1/5)

J2
1
2
3
4
5
6
Sheet2 - Input Voltage Selection.SchDoc Sheet4 - Main SMPS.SchDoc
F1 B06P-VL
S
ACDET ACDET +VB
-VB
J1
L PVAUX PVAUX +VDR
1 T12AH -VDR
2 PVSTART PVSTART
N PSEN
JST_B2P3_VH
PVBUS PVBUS +VAUX
-VAUX
PSVAUX PSVAUX nFATAL
OVL
nAMPON
J3
AMPOFF
+5VSB
+5VSB 1
2
+5VSB
3
4
5
6
7
Sheet3 - Standby SMPS.SchDoc
8
9
10
B10B-EH-A
PVBUS
+5VSB
PSVAUX
S

Sheet7 - Mechanical.SchDoc

MH2 MH1

C36 C35
100n 100n

S S


5.SMPS VM1.0(2/5)

HV
C15
AC2 i
S
VDC
1n PVBUS
HV HV
i i D3 D1
AC1 C1 C3 C5
L BYT79X-600 BYT79X-600 R122

1M
1000u 1000u 1000u
R54 R50

1M

1M

1
TR1
C8 220n 8
C14 TR3 2mH/8A C7
5
470n 2mH/8A 3 470n
R55 R51

1M

1M

3
6 4
R1
AC2 7 C2 C4 C6
N 12V R123

1M
1000u 1000u 1000u
i i 10R D4 D2 K1B
BYT79X-600 BYT79X-600
HV HV 12V 7
6 K2B 4
3
5 i
8 HV P
i
HV

PVAUX
C70 R120 R116
AC1 D44 AC2 T36 VDC
390k 390k
SS16 BCP56
10n
PSVAUX
PSVAUX PVSTART
C74

2
100k

100k
R97 R81 R113 100n
K2A D43

390k

100k
10k

10k
R91 R119 R112 R108
T37 180k 12V BAS316
R95 2k2
BC856BW P T43
T44

1
BC807W D32
180k

100k
R96 R114 BC856BW

8
U7A 12V

10k
R109
3 LM393
10k

R102
1 6
180k

100k

390k

10k
R100 BC846BW T41 R111 R110 R104
2 7
T39 T42 BC846BW
D40 5 P D36
BC846BW T38
C71 BAT54J U7B T40
BC846BW

4
220n LM393 BC817W
12V

2
U6
D39 TL431 C9 D41 K1A C73
100k

100k
10k

47k
2k2

R103 R101 R115 R106 R105

BAS316 22u BAS316 12V 100n

10k
R107

BAT54J
P P P P P P P P P D38 P P P P P P P P

D37
BAT54J
U3C
R124 D34 R90
PSVAUX 3 4
ACDET
2k2 LTV827S-V BAS316 1k

MAINS AC Detection Automatic MAINS Voltage Selection Inrush Current Limiter

P S
1n

HV
TR5
i SBY L5
PVBUS 1 7 +5VSB
65R/7A
C48 C45
C17 10n 100n
470n D10 C23 C31
P4SMA200A 1500u 1500u
P P S
D11 6 D13 15MQ040N
BYG20J HV
i C42 R29
2 S S
180p 10R
D8
PSVAUX 4
R45 R49 R43
SS16 10k 220R 10k
R38 C32
3

5k6 220u
U4C
LTV827S-V
3 C53
4

P
U1 100n
1
VCC DRAIN 3 P
R44
U2 10k
R25 TL431
FB 2
C28
6

100u 12R U4D

D17 S S
C41 15V LTV827S-V
GND 4 1n
5

NCP1014
P P P P

2
5.SMPS VM1.0(3/5)

i
+VB
PVBUS L1 1u/8A L3
P S +VB
C76 C75
L2 1u/8A
L4
1n C16
10n 10n R40 R35
T4 1u/8A 1u/8A

1
HV C54 C49
10R T3 10R
P P C72 TR2 D21 220p D14 FDP61N20 220p
R121 i FDP61N20
T1 220p TR4G 3 12 BAW56W R42 TR4F 3 11 BAW56W R37 C18 C19 C30 R26
C39
1

HV SPW32N50 68R 68R 220u 220u 220u 47k

10R 100n
D42 R99
TR4A i
2 3 BAW56W T45 68R 14 T20 T19

2
BC807 BC807 R39 BC807 R34
R41 68R R36 68R S S S S S
T46 13 1k 10 1k
2

BC817 R98 TCT15 TCT15

R118 R117 68R HV
1 1k 100R i R17 R10
1 12 S S S S S
TCT15 T6

1
C43 C38

1
T5
10R 220p 10R 220p
D9 FDP61N20 D5 FDP61N20
3 8 BAW56W TR4D 3 7 BAW56W
S TR4E R28 R2
68R 68R C29 C34 C33 R4
C69 220u 220u 220u C37 47k
R65 T2 220p 100n
T17 T11
1

2
SPW32N50 13 BC807 R18 BC807 R3
10R L9 1u/8A L7 1u/8A
D22 R86 R19 68R R11 68R
TR4B 3 3 BAW56W T22 68R C10 9 1k 9 1k
470n L8 L6
BC807 TCT15
TCT15 -VB
1u/8A 1u/8A
T21 HV -VB
2

BC817 R79 i
R64 R63 68R 3
4 1k 100R D18 +VDR
L10
TCT15 ISEN 11
+VDR
330R/1.5A
R69 MURA220T3
C12 R48 C50
0R018 C20 C25
470n 220u 220u
12R 1n
L11
10
-VDR
P P 330R/1.5A
D35 -VDR
R46 C51
7 Sheet6 - Seconday Control.SchDoc
PVAUX
SS16 12R 1n
D19 +VAUX
L12 PSEN PSEN
9
+VAUX +5VSB +5VSB
330R/1.5A nAMPON nAMPON
MURA220T3 C21 C26
6 220u 220u
AMPOFF AMPOFF
C11
nFATAL nFATAL
220u P 8 S S VSW
VSW
R47 C52 OVL OVL
5 S
12R 1n
D20 -VAUX
L13
P
-VAUX
330R/1.5A
MURA220T3
C22 C27
Sheet5 - Main SMPS Control.SchDoc
220u 220u

PSVAUX PSVAUX PTC

S S
VSW
PVSTART PVCTRL
TCT57
ISEN
ACDET PROT ISEN

21
5.SMPS VM1.0(4/5)

T24
BCP56
PSVAUX PVCTRL
U4B R61
8 7
1k
C13
D27
LTV827S-V 22u
12V

P P
VCTRL

C63 R93 R74 R78

100n 100k 10R 10R

T28 R72 R56 R89 R52 R88 R62 C60 R53

14

13

12
BC856BW 10k 47k 47k C67 C65 47k 2k2 C55 1k 1u 1k
R92 R94 1n 1u 1u D28 D24
D31 D26 R71

EF

PC TL

CC
PROT T32 BAT54J BAT54J

RREF
47k 10k P

VVCC
OOPCTL
BC856BW 1 8
BAS316 BAS316 1k 1I
1IN+
IN+ C11
C
T29
TR4C
T26
D33 C56
T35 R82 2 BC817W
1I
1IN-
IN-

6
BC846BW R58 1k 9 TCT15
BAS316 C61 E11
E 1u
R85 D25 220k 16 T30
R66 100n 2IN+
2I
IN+

BC856BW
C68 100k BC807W D29 D23 T25
100n 15 BAT54J BAT54J
PTC BAS316 10k R68 T27
2I
2IN-
IN-
100k P 11
C22
C
P P P R59 4
DTC
D TC
47k P P
T23 3 10
FB E22
E
BC846BW

ND
GGND
R60

CCTT

RRTT
C57 22k PROT
100n D30

7
U5
T31 TL494
C64
BC846BW R76 R77 R87 BAS316 R75
PROT
C58 R67 C62 R73 47k 47k 1k2 18k
470p
1u 1M 1u 1M

P P P P P P P P P P P

VCTRL

R57
2k2
1

ISEN
U3A
LTV827S-V
R80 R83
2

3k3 2k2

T34 T33
BC846BW BC846BW

R70 R84
10k C59 10k C66
1n 1n

P P P P P P

2
5.SMPS VM1.0(5/5)

R30

1k Heatsink to PCB
Assembly
R31 R27 Ass1 HS1
47k C44 47k C40 Mechanical Mechanical Mechanical Mechanical
220n T16 100n M3x12 M3x12 3x5x7,5mm 3x5x7,5mm
nAMPON Bare PCB SAA19L3W0H8T1
BC856BW
PCB1
1

D16 S S
R24 T13
3 BAW56W SMPS_ON
VSW
T15 BC846BW Heatsink to L-Profile
47k
BC856BW R20
R21 47k
2

S 47k Mechanical Mechanical Mechanical HS2

D12 M3x6 M3x6 M3x6 ST1 ST2
R32
BAS316 ST3
1M Mechanical Mechanical Mechanical SBA19L12W5H3T1
S T14 S M3x6 M3x6 M3x6
R33 D15
T18 BC846BWR23
AMPOFF
BC846BW
1M 5V6 47k
R22
C47 C46 47k
1u 100n PCB to L-Profile

Mechanical Mechanical Mechanical Mechanical Mechanical Mechanical

S S S S S M3x16 SpringwasherM3 M3 3x5x10mm M3 M3x6

Mechanical Mechanical Mechanical Mechanical Mechanical

M3x16 SpringwasherM3 M3 3x5x10mm M3
+5VSB

R8 R13
PSEN C77
10k 1k FETs/Diodes to Heatsink
T9 100n
BC856BW T12
nFATAL
BC856BW Mechanical Mechanical Mechanical Mechanical Mechanical Mechanical Mechanical
Spring Clamp Spring Clamp Spring Clamp Spring Clamp Spring Clamp 58x55 30x55mm
R9 R5 R12 Mechanical Mechanical Mechanical Mechanical Mechanical Mechanical
OVL
22k 22k 10k Spring Clamp Spring Clamp Spring Clamp Spring Clamp Spring Clamp 49x55
R15 R7 R14
220R 2k2 2k2
T10 D6 T7
BC846BW BC846BW
T8 FETs
BAS316 BC846BW
1

Mechanical Mechanical Mechanical Mechanical

U4A R6 R16 U3D U3B
D7 25x20 Coppertape19mm Coppertape19mm Coppertape19mm
LTV827S-V 47k C78 1k LTV827S-VLTV827S-V
BAS316 100n Mechanical Mechanical Mechanical Mechanical
2

25x20 Coppertape19mm Coppertape19mm Coppertape 19mm

S S S S S S S S S

23
6.SMPS STB VM1.0

CY301

1
D303
TVS SMAJ200A 1nF/AC250V

2 3
1 T301
C301
SS36 60V/3A
400V/10UF
D301 D305 L301 5VDS
B6S 10

4
3
R301 10R Comment: 10UH
C303 C304
100PF/1KV 4
C305 C306
C311 D304 1000uF/10V 1000uF/10V
BYG20J 600V/1.5A 100nF/50V 100nF/50V
BAS321 9
D302
TH301 5

120-- 240V AC :T1.25A L/250V

SCK10054 5R/4A DSGND
TNY274 IC301 C302 EE16E
10uF/50V
5 4
S D
R305
6 22K
F301 S R306
C307
FUSE1 7 2 100R
S BP
OP301 PC817
8 1 100nF/50V R310
S UV R307
2.2K 1%
1k

DW301
18V/3W SMA C308
10k R308

3
100nF/50V
1
GNDP
IC302

2
TL431
R309
2.2K 1%
P301
1
AC-L R302
180k
8

J302
A C90V /230v±10%

CX301
4

1
5VDS
M AI N I N

3
NC

NC
D2

D2

1UF/275VAC
CA P017D G
330K N C
14D 471K

L302 L303 DSGND 2

Z V 301

CX302 CX303
R303

IC303

4mH/9A 470nF/275VAC 8mH/9A 100nF/275VAC STB 1

CON3
NC

NC
D1

D1

2
1

R304
180k
P302
1
AC-N

CY302 CY303
1nF/AC250V 1nF/AC250V
XM301

K301 5VDS
JQX-105F DC5V
1

HOLE
D306
1N4148
2

Q301
L304 Comment: 2SC2878
Comment: 550UH B R311
STB
220R
R312
C309 4.7K 1%
E

N L 100P
1
2
3

DSGND
J303
TO-PSU1

24
PCB LAYOUT
1.MCU VM1.0 BOARD

Top Layer

Bottom Layer

25
2.AMP VM1.0 BOARD

Top Layer Bottom Layer

2
3.NC400 OEM VM1.0 BOARD

Top Layer Bottom Layer

2
4.TRIGGER VM1.1 BOARD

Top Layer Bottom Layer

5.TOUCH VM1.1 BOARD

Top Layer Bottom Layer

6.LED VM1.1 BOARD

Top Layer Bottom Layer


5.SMPS VM1.0 BOARD

Top Layer

Bottom Layer


6.SMPS STB VM1.0 BOARD

Top Layer

Bottom Layer

3
 ELECTRICAL PARTS LIST

PCB-1: MCU BOARD

CIRCUIT NO. PART NO. DESCRIPTION
A16-62201-21 MCU Board VM1.0,FR-4,1.6mm,2Layers,2oz, TG130
DIODES
D166, D167 33-44148-16 Switch Diode SMD CD4148WP
D101, D104, D109, D111, D134,
D135, D136, D137, D139, D140, 33-40352-01 Switch Diode 1SS352(TPH3,F),1SS355TE-17
D141, D142, D146, D147
D105, D106, D107, D112, D113,
33-14709-09 Zener Diode BZT52C4V7,4.7V,350mW
D114, D123, D158,D159,D160
D154,D162,D163 33-40099-02 Switch Diode BAV99-7-F

D168,D169 33-11600-02 Zener Diode BZT52C16-7-F,16V,500mW,6%

D118, D119, D155 33-13609-03 Zener Diode BZT52C3V6,3.6V,350mW
Surface Mount Schottky
D124 33-20012-01 SS12 SMA
Barrier Rectifier
D110, D170 33-11500-06 Zener Diode BZT52C15,15V,350mW
TRANSISTORS
Q131 31-00114-01 Digital transistor DTA114EKA
Q105, Q135 31-00114-05 Digital transistor DTC114EKA
Q132 31-02301-01 P-CH MOSFET APM2301CAC, SOT23, Tape

Q125,Q126 31-00856-01 Transistor BC856B,SOT23

Q121,Q122 31-00846-01 Transistor BC846B,SOT23

Q104, Q117 31-01312-00 Transistor 2SA1312GR(TE85L,F) TO-236MOD
Q113 31-00062-00 Transistor BCV62B SOT143B
Q118 31-03324-00 Transistor 2SC3324-GR(TE85L,F) TO-236MOD
Q120 31-00593-00 Transistor XSTR,FMMT593,PNP,100V
ICS
U100 03-00324-01 Low Power Quad OpAmp LM324ADR
U102 03-00084-03 Quad OPAMP TL084CD/TL084CDR
U105 03-01826-26B MCU PIC18F26K20-I/SS(M22 V2.1 program ）
U105 03-01826-01 MCU PIC18F26K20-I/SS
U108 03-01117-06 Regulator AMS1117 －3.3
U109 03-00717-01 Buffer NC7WZ17P6X
U104 03-00595-01 Shift Register 74HC595D,118
RESISTOR
R119, R120, R121, R123, R126,
R128, R130, R131, R133, R135,
R158, R161, R168, R169, R170, 07-90000-00 Chip Resistor 0Ω, 0603, ±5%
R172, R174, R177, R178, R202,
R240, R244
180KΩ,0603,1/10W,±1%,RC0603FR-
R203,R210 07-91803-00 Chip resistor
07180KL
10Ω,0603,1/10W,±1%,RC0603FR-
R114, R290 07-91009-00 Chip resistor
0710RL
R124,R139, R141, R186, R219,
R220, R222, R223, R225, R226, 100Ω,0603,1/10W,±1%,RC0603FR-
07-91000-00 Chip Resistor
R228, R229, R231, R232, R233, 07100RL
R235, R245, R268, R269
R286, R289 07-91200-00 Chip Resistor 120Ω,0603,1/10W,±1%
200Ω,0603,1/10W,±1%,RC0603FR-
R136, R137 07-92000-00 Chip Resistor
07200RL
1KΩ,0603,1/10W,±1%,RC0603FR-
R100, R176, R201 07-91001-00 Chip Resistor
071KL

31
 7.5KΩ,0603,1/10W,±1%,RC0603FR-
R180 07-97501-00 Chip Resistor
077K5L
12KΩ,0603,1/10W,±1%,RC0603FR-
R163 07-91202-00 Chip Resistor
0712KL
R328 07-94301-00 Chip resistor 4.3KΩ,0603,1/10W,±1%,

R323,R324 07-94707-03 Chip Resistor 0.47Ω, 1210, ±1% RL1210FR-070R47L

R165, R341,R342 07-93901-00 Chip resistor 3.9KΩ,0603,1/10W,±1%,

R338,R339,R340,R346, R347,
07-96800-00 Chip Resistor 680Ω,0603,1/10W,±1%,
R348

R107, R108, R151, ,R167, R185,

R208, R214, R239, R241, R296, 10KΩ,0603,1/10W,±1%,RC0603FR-
07-91002-00 Chip Resistor
R297, R309, R329, R330, R331, 0710KL
R349

R336,R337 07-94700-00 Chip Resistor 470Ω,0603,1/10W,±1%,

1.5KΩ,0603,1/10W,±1%,RC0603FR-
R319 07-91501-00 Chip resistor
071K5L
5.1KΩ,0603,1/10W,±1%,RC0603FR-
R122, R175 07-95101-00 Chip Resistor
075K1L
5.6KΩ,0603,1/10W,±1%,RC0603FR-
R112, R113 07-95601-00 Chip resistor
075K6L
15KΩ,0603,1/10W,±1%,RC0603FR-
R115, R125 07-91502-00 Chip Resistor
0715KL
R173, R179, 22KΩ,0603,1/10W,±1%,RC0603FR-
07-92202-00 Chip resistor
R216,R333,R335,R332,R334 0722KL
R325 07-93302-00 Chip resistor 33KΩ,0603,1/10W,±1%,
47KΩ,0603,1/10W,±1%,RC0603FR-
R101, R160,R164,R285 07-94702-00 Chip Resistor
0747KL
100KΩ,0603,1/10W,±1%,RC0603FR-
R111, R116, R117, R127, R129 07-91003-00 Chip resistor
07100KL
120KΩ,0603,1/10W,±1%,RC0603FR-
R326, R327 07-91203-00 Chip resistor
07120KL
330KΩ,0603,1/10W,±1%,RC0603FR-
R152, R153 07-93303-00 Chip resistor
07330KLT
100Ω,0805,1/8W,±5%,RC0805JR-
R282, R283, R291, R292, R293 07-90101-01 Chip Resistor
07100RL
R144 07-92505-07 Chip Resistor WSR32L500FEA,2.5mΩ, ±1%,3W
R144 Or Chip Resistor LRS1050,2.5mR,3W,±1%
R209, R213 07-90101-10 Chip Resistor NET 100Ω, ±5% R0603X4
JP100, JP101, JP102 69-047001-0 Bus Bar
R171 09-02103-05 Variable Resistor 10KΩ,±10%,3362P-1-103LF
INSTALL COPPER
85-000002-0 Moveable Bushing KG-010N, 260mm
210mm*3
CAPACTIOR
47PJ,50V,0805,NPO,C2012C0G1H470J
C178, C179 26-47051-01 Ceramic Chip Capacitor
T
C146 26-10251-00 Ceramic Chip Capacitor 1nK,50V,0603,X7R
C107, C116, C117 26-22251-00 Ceramic Chip Capacitor 2n2K,50V,0603,X7R
C101, C102, C108, C109, 10nK,50V,0603,X7R,C2012X7R1H103K
26-10351-00 Ceramic Capacitor SMD
C115,C159 T

C180,C183 26-10611-21 Ceramic Chip Capacitor 10uK,16V,0805,X5R

C181,C182 26-10521-01 Ceramic Chip Capacitor 1uK,25V,0805,X7R

32
C104, C122, C124, C125, C129,
C132, C133, C136, C139, C140,
26-10451-10 Ceramic Chip Capacitor 100nK,50V,0603,X7R
C143, C147, C152, C155, C158,
C164, C173
C112 26-47111-00 Ceramic Capacitor SMD 470nF,16V,0603,10%, X5R
C114 26-10511-20 Ceramic Capacitor SMD 1uK,16V,0603,X7R
10uK,10V,0603,X7R
ECJ1VB1C106J/ECJ1VB1H106J/ECJ1
C103, C105 26-10611-10 Ceramic Chip Capacitor VB1E106J/C0603C106K8RAC/C0603C
106K4RAC/C0603C106K3RAC/C0603C
106K5RAC
C162, C163, C166, C167, C168 26-22351-01 Ceramic Chip Capacitor 22nK,50V,0805,X7R
C138, C151, C174 26-22660-11 Ceramic Chip Capacitor 22uF, 6.3V, X5R, 0805
C100 26-22411-10 Ceramic Chip Capacitor 220nF,16V, X7R, 0603
10uF, 25V, X5R, 1206,
C177,C184 26-10621-12 Ceramic Chip Capacitor
C3216X5R1E106KT
C113 06-10031-01 Alu Electrolytic Capacitor CD70H,10uF,35V,±20%,105 ℃,F2.5
C123, C126, C127, C128, C130, CD289,220uF,35V,20%,D=8mm,Pitch=3
06-22131-05 Alu Electrolytic Capacitor
C131 .5mm
CD287,470uF,10V,±20%,Pitch=3.5mm
C156 06-47111-10 Alu Electrolytic Capacitor
D=8mm
INDUCTOR
FB100 08-04601-10 Bead CBA321609-4U-601
742792662,
L101, L102, L103 08-04102-31 Chip Ferrite Bead
1000ohm@100MHz,Imax=600mA
TRANSISTORS
Q124 31-01220-00 Power Transistor KSA1220AYS,TO-126

Q123 31-02690-00 Transistor KSC2690AYS TO-126

CONNECTORS
2mmPitch,2*4Pin,CNT-B200-2*4-GS-
CON106 13-22008-05 IDC connector
2.8-N
TP1 13-10001-22 Test Pin CNT-M254-1*1-GS-GS-6/3-N
P109 13-22504-20 Connector Socket XHB2.5A-4A, Gold plated SIP4A
P112 13-22503-00 Connector Socket XHB2.5A-3A
P111 13-22504-00 Connector Socket XHB 2.5A-4A/TJC3-4A
2.54Pitch,5Pin,CNT-M254-1*5-GS-6/2.5-
CON103 13-12505-18 Connector
N
2.54mmPitch,2*18Pin,gold-plating
13-22536-04 2.54 Connector
5u'',BHA2900P18CCA01
2.54mmPitch,2*18Pin,gold-plating
or 2.54 Connector
,TSS-118-01-L-D,
2X3P MV 6.2mm PCB JST,JST VL-
P105 13-26206-00 Connecter
series
P103 13-22510-23 Connector CNT-1132-10
INSTALLQ123, Q124 70-048004-0 Small Heatsink 6063 T5 TBD
INSTALLQ123, Q124 61-023206-0 Self Tapping Screw BTB3×6,black zinc plated
INSTALLQ123, Q124 61-023208-0 Self Tapping Screw BTB3×8,black zinc plated
PCB-2: AMP BOARD
CIRCUIT NO. PART NO. DESCRIPTION

VM1.0,FR-4,1.6mm,4Layers,Top,Bottom
A16-62202-21 AMP PCB
2oz,Mid 1oz,TG130,161.5×95.5mm,
VM1.0,FR-4,1.6mm,4Layers,Top,Bottom
A16-62220-21 AMP PCB ASSM
2oz,Mid 1oz,TG130,174.5×105.5mm

33
 DIODES

D518,D519 33-14709-09 Zener Diode BZT52C4V7,4.7V,350mW

D501, D502, D503, D504, D505,

D506, D507, D508, D509, D510, 33-40352-01 Switch Diode 1SS355TE-17
D511, D512, D513, D514, D516
LED(Red/Green Dual
D500 33-50325-10 Φ3mm Red&Green,AC,BL-BEG201Q-B
Color)
TRANSISTORS
Q500, Q508 31-00114-01 Digital transistor DTA114EKA
Q501, Q502 31-00114-05 Digital transistor DTC114EKA
Q503, Q504 31-01015-03 Transistor A1015, SOT23
Q505, Q506 31-01815-03 Transistor C1815 SOT23
ICS
U500, U501 03-49720-01 Dual OPAMP LME49720MA/NOPB
U502 03-00072-01 Dual OPAMP TL072CD/TL072CDR
U503 03-02134-00 Dual OPAMP OPA2134UA/2K5E4 SO-8
U504 03-06002-01 Dual OPAMP MCP6002T-E/SN
3-Terminal Adjustable
U505 03-00317-00 LM317T
Regulator
U506 03-00337-00 3-Terminal Regulator LM337T
RESISTOR
R561, R563, R570, R571, R585 07-90000-00 Chip Resistor 0Ω, 0603, ±5%
10Ω,0603,1/10W,±1%,RC0603FR-
R541, R543, R551, R588, R589 07-91009-00 Chip resistor
0710RL
100Ω,0603,1/10W,±1%,RC0603FR-
R506, R536 07-91000-00 Chip Resistor
07100RL
316Ω,0805,1/8W,±1%,RC0805FR-
R581 07-93160-01 Chip Resistor
07316RL
309Ω,0805,1/8W,±1%,RC0805FR-
R576 07-93090-01 Chip Resistor
07309RL
1KΩ,0603,1/10W,±1%,RC0603FR-
R505, R595 07-91001-00 Chip Resistor
071KL
3.24KΩ,1/10W,±1%,0603,RC0603FR-
R577, R580 07-93241-00 Chip Resistor
073K24L
R594 07-91201-92 Chip resistor MMF204FRE1K2R,1.2KΩ,±1%,
5.6KΩ,0603,1/10W,±1%,RC0603FR-
R550 07-95601-00 Chip resistor
075K6L
6.8KΩ,0603,1/10W,±1%,RC0603FR-
R500, R564, R575 07-96801-00 Chip resistor
076K8L
R503, R504, R515, R528, R539, 10KΩ,0603,1/10W,±1%,RC0603FR-
07-91002-00 Chip Resistor
R552, R556, R557, R590 0710KL
R545 07-94701-00 Chip Resistor 4.7KΩ,0603,1/10W,±1%
10.2KΩ,0603,1/10W,±1%,RC0603FR-
R544, R548, R549 07-91022-00 Chip Resistor
0710K2L
12KΩ,0603,1/10W,±1%,RC0603FR-
R507, R538 07-91202-00 Chip Resistor
0712KL
R593 07-91302-00 Chip Resistor 13KΩ,0603,1/10W,±1%
22KΩ,0603,1/10W,±1%,RC0603FR-
R568, R573 07-92202-00 Chip resistor
0722KL
R502 07-93302-00 Chip resistor 33KΩ,0603,1/10W,±1%,

34
R540 07-94121-00 Chip resistor 4.12KΩ,0603,1/10W,±1%
R510, R511, R517, R531, R535, 47KΩ,0603,1/10W,±1%,RC0603FR-
07-94702-00 Chip Resistor
R569, R574 0747KL
100KΩ,0603,1/10W,±1%,RC0603FR-
R560, R562 07-91003-00 Chip resistor
07100KL
220KΩ,0603,1/10W,±1%,RC0603FR-
R512, R533, R516, R530 07-92203-00 Chip resistor
07220KL
330KΩ,0603,1/10W,±5%,RC0603JR-
R553 07-90334-00 Chip Resistor
07330KL
100Ω,0805,1/8W,±1%,RC0805FR-
R586 07-91000-01 Chip resistor
07100RL
R501, R554, R555, R578, R579, 100Ω,0805,1/8W,±5%,RC0805JR-
07-90101-01 Chip Resistor
R584 07100RL
10KΩ,0805,1/8W,±5%,RC0805JR-
R514, R518, R521, R529 07-90103-01 Chip Resistor
0710KL
R508, R534, R509, R537 07-94751-92 MELF Resistors MMF204FRE4K75,4.75KΩ,1/4W,±1%
MMF204FRE3.3R,3.3Ω,0.4W,±1%,
R572, R582 07-93308-92 MELF Resistors
3.45*1.35*0.6mm
MMF204FRE2K43,2.43KΩ,0.4W,±1%,
R520, R527 07-92431-92 MELF Resistors
3.45*1.35*0.6mm
MMF204FRE4K64,4.64KΩ,0.4W,±1%,
R513, R532 07-94641-92 MELF Resistors
3.45*1.35*0.6mm
R546, R558 07-90225-02 Chip Resistor 2.2MΩ, 1/4W,±1%
100Ω,1206,1/4W,±1%,RC1206FR-
R522 07-91000-02 Chip Resistor
07100RL
680KΩ,0603,1/10W,±1%,RC0603FR-
R547, R559 07-96803-00 Chip Resistor
07680KL
C524, C529 26-10351-11 Ceramic Capacitor SMD 10nJ,50V,0805,NPO
C502, C508, C521 26-10511-20 Ceramic Capacitor SMD 1uK,16V,0603,X7R
R587 07-90475-02 Chip Resistor 4.7MΩ, 1/4W,±1%
MMF204FRE845R,845Ω,0.4W,±1%,
R523 07-98450-92 Chip Resistor
3.45*1.35*0.6mm
MMF204FRE392R,392Ω,0.4W,±1%,
R525 07-93920-92 MELF Resistors
3.45*1.35*0.6mm
R526 07-94703-92 Chip Resistor MMF204FRE470K, 470KΩ, ±1%
R524 09-02501-04 Variable Resistor 500Ω,±10%3362P-1-501LF
R542 09-02502-04 Variable Resistor 5KΩ,±10%3362P-1-502LF
21-06300-00 Link(φ0.6) L=3mm

CAPACTIOR
100pJ,50V,0603,NPO,C1608C0G1H101
C558, C500, C512 26-10151-00 Ceramic Chip Capacitor
JT
C501, C509 26-22151-00 Ceramic Chip Capacitor 220PJ,50V,0603,NPO
C504, C506, C515, C516, C519,
26-10451-10 Ceramic Chip Capacitor 100nK,50V,0603,X7R
C520, C523, C557
C567, C568 26-10521-00 Ceramic Capacitor SMD 1uFZ,25V,0603,Y5V
10nK,250V,0805,X7R
C553, C554 26-10322-11 Ceramic Capacitor SMD
CC0805KKX7RYBB103
C527, C528, C536, C537, C565,
26-22351-01 Ceramic Chip Capacitor 22nK,50V,0805,X7R
C566
C533, C539, C548, C552, C569 26-10451-01 Ceramic Chip Capacitor 100nZ,50V,0805,Y5V
C526 26-10521-01 Ceramic Chip Capacitor 1uK,25V,0805,X7R
C530, C531, C534, C544, C545, 10uK,16V,0805,X5R,C2012X5R1C106K
26-10611-21 Ceramic Chip Capacitor
C556, C571 T / CC0805KKX5R7BB106

35
C541, C549, C507, C511 26-10352-02 Ceramic Chip Capacitor 1206, 10nF, 500V, X7R, ±10%
C538, C547, C510, C513, C540, 10uF, 25V, X5R, 1206,
26-10621-12 Ceramic Chip Capacitor
C543, C555 C3216X5R1E106KT
330nK,250V,1210,X7T
C542, C550 26-33422-03 Ceramic Capacitor SMD
C3225X7T2E334KT000N
C535, C546, C559, C560, C561, 100uF,100V,10×20mm, ±20%,105 ℃
06-10112-07 Alu Electrolytic Capacitor
C562, C563, C564 WL2A107M10020BB180
C525 06-22111-04 Alu Electrolytic Capacitor CD263(X),220uF,10V,±20%,F2.5
C503, C505 06-10011-03 Alu Electrolytic Capacitor CD263(X),10uF,16V,±20%,105℃,F2.5
EEUFC1E101SH,100uF,25V,±20%,105
C514, C517, C532, C551 06-10121-14 ALU Electrolytic Capacitor
℃
C518, C522 06-47021-15 ALU Electrolytic Capacitor 47uF,25V,±20%,105℃,EEUFC1E470(H)
Metallized Polyester Film
C570 25-18261-00 ASS21,1800pF, 63V, ±5%
Capacitor
INDUCTOR
L501, L503 08-04158-00 Inductor SMD 150nH 744302015
L502, L504, L505, L506, L507 08-04102-11 Chip Bead 74279205 1000ohm@100MHz
Common-Mode Choke
T500, T501 08-04161-00 744232161, 160ohm@100MHz 340mA
Coils
CONNECTORS
TP2 13-10001-22 Test Pin CNT-M254-1*1-GS-GS-6/3-N
J500 17-01001-12 RCA WHITE
J502 J17-09003-28 Mic Connector NC3FAAH2
2.54mmPitch,2*18Pin,Gold Plating
P500 13-22536-05 2.54 Connector
5u",FHB2850Y18SCA55
P500 or 2.54 Connector 2.54mmPitch,2*18Pin,ASP-174743-01
2.54mmPitch,2*18Pin ,Gold Plating
P502 13-22536-06 2.54 Connector
5u",3F85R2118S5BYE2
2.54mmPitch,2*18Pin,Gold
P502 or 2.54 Connector
Plating,SSW-118-02-L-D-RA-N,
RL500 12-02202-22 Relay HFD31/5-L1
RL500 or relay 769-TQ2-L-5V
S500 11-06102-05 Toggle Switches 2AS1T2A1M6RES
BINDING POST ---PCB 14-62202-11 Wire UL3135#16AWG, L=130mm,105 ℃
CN501 CN502 32-26308-06 Connecter KY250
85-375004-0 LED Spacer LED3*4
76-000001-0 Teflon 18AWG-L
JP500 69-355001-0 Bus-Bar T2Y2 T=1mm
PCB-3: NC400 OEM
BOARD
CIRCUIT NO. PART NO. DESCRIPTION
VM1.0,FR-4,1.6mm,4Layers,Top,Bottom
A16-62203-21 NC400 OEM PCB
2oz,Mid 1oz,TG130,82×63mm

VM1.0,FR-4,1.6mm,4Layers,Top,Bottom
A16-62220-21 AMP PCB ASSM
2oz,Mid 1oz,TG130,174.5×105.5mm
DIODES
D28 33-11000-03 Zener Diode 10V 0.4W, PDZ10B
D21, D23 33-11200-05 Zener Diode PDZ12B 12V 0.4W SOD323
D6 33-11500-05 Zener Diode PDZ15B 15V 0.4W SOD323
D5, D13 33-12409-02 Zener Diode 2.4V,PDZ2.4B
D16, D18 33-13309-04 Zener Diode PDZ3.3B
D20 33-13909-04 Zener Diode PDZ3.9B 3.9V,0.4W,SOD323
D10, D14, D27 33-15609-06 Zener Diode PDZ5.6B 5.6V,0.4W,SOD323
D9 33-40056-00 High speed Diode BAW56W SOT323

36
D4, D12 33-40070-00 High speed Diode BAV70W
D1, D2, D7, D8 33-40099-02 High speed Diode BAV99W-7-F
D3, D11, D15, D19, D22, D24,
33-20316-01 High speed Diode BAS316
D25, D26, D29
TRANSISTORS
T4, T11 31-00718-01 Transistor FMMT718
T1, T6 31-00618-01 Transistor FMMT618
T10, T13, T21, T22, T26, T29,
31-00846-02 Transistor BC846BW SOT323
T31, T34, T36, T38, T41, T42
T18, T19 31-00846-05 Transistor BC846AS-7,100mA 65V
T7, T25, T28 31-00856-03 Transistor BC856BW SOT323
T23 31-05401-05 Transistor MMST5401-7-F
T14, T16, T17 31-00856-05 Transistor BC856AS-7,100mA 65V
T15, T20 31-00856-04 Transistor BCM856S SOT363
T39 31-00056-01 Transistor BCP56 SOT223
T30, T37 31-00061-00 Transistor BCV61B SOT143B
T24, T32 31-00062-00 Transistor BCV62B SOT143B
T5 31-00622-01 Transistor BF622
T3, T9 31-03906-02 Transistor MBT3906DW1T1G
T12, T33 31-05401-01 Transistor MMBT5401LT1G, SOT-23
T35 31-05551-01 Transistor MMBT5551LT1G, SOT-23
T40 31-00139-01 Transistor BD139 SOT-32
T2, T8 31-05220-00 MOSFET FDP52N20,TO220F
ICS
U1 03-05532-03 amp NE5532DR SOIC8
PIC16F690-I/SO(NC400-PIC-
U2 03-16690-12 MCU
V1.00Progarm）
U2 03-16690-01 MCU PIC16F690-I/SO
RESISTORS
Professional MELF
R49, R86 07-98200-91 820Ω, ±1%, MMU01020C8200FB300
Resistors
Professional MELF
R57, R58, R74, R75 07-91201-91 1.2KΩ, ±1%, MMU01020C1201FB300
Resistors
Professional MELF
R60, R63, R72, R77 07-91501-91 1.5KΩ, ±1%, MMU01020C1501FB300
Resistors
Professional MELF 2.7KΩ,0102,±
R56, R80 07-92701-91
Resistors 1%,MMU01020C2701FB300
Professional MELF
R50, R85 07-93001-91 3KΩ,0102,±1%,MMU01020C3001FB300
Resistors
Professional MELF
R52, R84 07-91002-91 10KΩ, ±1%, MMU01020C1002FB300
Resistors
R2, R3, R4, R5, R6, R7, R19,
R20, R21, R26, R27, R28, R41, 07-91008-00 Chip Resistor 1Ω,0603,1/10W,±1%,RC0603FR-071RL
R43, R44, R45, R46, R47, R144
2.2Ω,0603,1/10W,±1%,RC0603FR-
R13, R24, R33 07-92208-00 Chip Resistor
072R2L
4.7Ω,0603,1/10W,±1%,RC0603FR-
R1, R23 07-94708-00 Chip Resistor
074R7L
47Ω,0603,1/10W,±1%,RC0603FR-
R93 07-94709-00 Chip Resistor
0747RLT
82Ω,0603,1/10W,±1%,RC0603FR-
R94, R112, R135 07-98209-00 Chip Resistor
0782RL
100Ω,0603,1/10W,±1%,RC0603FR-
R99 07-91000-00 &KLS5HVLVWRU
07100RL
R90 07-91200-00 Chip Resistor 120Ω,0603,1/10W,±1%
220Ω,0603,1/10W,±1%,RC0603FR-
R12, R32, R48 07-92200-00 Chip Resistor
07220RL

37
 270Ω,0603,1/10W,±1%,RC0603FR-
R81, R82 07-92700-00 Chip Resistor
07270RL
330Ω,0603,1/10W,±1%,RC0603FR-
R106, R109 07-93300-00 Chip Resistor
07330RL
470Ω,0603,1/10W,±1%,RC0603FR-
R11, R31 07-94700-00 Chip Resistor
07470RL
560Ω,0603,1/10W,±1%,RC0603FR-
R69, R73, R83, R89 07-95600-00 Chip Resistor
07560RL
R34, R38, R39, R55, R87, R88, 1KΩ,0603,1/10W,±1%,RC0603FR-
07-91001-00 Chip Resistor
R103, R115, R121, R128 071KL
1.2KΩ,0603,1/10W,±1%,RC0603FR-
R142 07-91201-00 Chip Resistor
071K2L
1.8KΩ,0603,1/10W,±1%,RC0603FR-
R122, R143 07-91801-00 Chip Resistor
071K8L
2.2KΩ,0603,1/10W,±1%,RC0603FR-
R40, R110, R120 07-92201-00 Chip Resistor
072K2L
2.7KΩ,0603,1/10W,±1%,RC0603FR-
R67, R68 07-92701-00 Chip Resistor
072K7L
4.7KΩ,0603,1/10W,±1%,RC0603FR-
R91, R95, R136 07-94701-00 Chip Resistor
074K7L
6.8KΩ,0603,1/10W,±1%,RC0603FR-
R53, R54 07-96801-00 Chip Resistor
076K8L
8.2KΩ,0603,1/10W,±1%,RC0603FR-
R119 07-98201-00 Chip Resistor
078K2L
R10, R29, R30, R70, R96, R98,
10KΩ,0603,1/10W,±1%,RC0603FR-
R101, R102, R117, R118, R127, 07-91002-00 Chip Resistor
0710KL
R140, R141, R152, R153
12KΩ,0603,1/10W,±1%,RC0603FR-
R145, R151 07-91202-00 Chip Resistor
0712KL
13KΩ,0603,1/10W,±1%,RC0603FR-
R150 07-91302-00 Chip Resistor
0713KL
22KΩ,0603,1/10W,±1%,RC0603FR-
R97, R100 07-92202-00 Chip Resistor
0722KL
R116, R123, R124, R139 07-92702-00 Chip Resistor 27KΩ,0603,1/10W,±1%,
18KΩ,0603,1/10W,±1%,RC0603FR-
R149 07-91802-00 Chip Resistor
0718KL
47KΩ,0603,1/10W,±1%,RC0603FR-
R66, R71 07-94702-00 Chip Resistor
0747KL
100KΩ,0603,1/10W,±1%,RC0603FR-
R16, R36, R51, R138 07-91003-00 Chip Resistor
07100KL
150KΩ,0603,1/10W,±1%,RC0603FR-
R113, R131 07-91503-00 Chip Resistor
07150KL
390KΩ,0603,1/10W,±1%,RC0603FR-
R130, R133 07-93903-00 Chip Resistor
07390KL
1MΩ,0603,1/10W,±1%,RC0603FR-
R25, R134 07-91004-00 Chip resistor
071ML
10Ω,0805,1/10W,±1%,RC0805FR-
R14 07-91009-01 chip Resistor
0710RL
47Ω,0805,1/8W,±1%,RC0805FR-
R64 07-94709-01 Chip Resistor
0747RL
68Ω,0805,1/8W,±1%,RC0805FR-
R148 07-96809-01 Chip Resistor
0768RL
R17, R37 07-91001-01 chip Resistor 1KΩ,0805,1/8W,±1%,RC0805FR-071KL
1.8KΩ,0805,1/8W,±1%,RC0805FR-
R65 07-91801-01 Chip Resistor
071K8L
47KΩ,0805,1/8W,±1%,RC0805FR-
R59, R76, R146, R147 07-94702-01 Chip Resistor
0747KL

38
 360KΩ,0805,1/8W,±1% RC0805FR-
R61, R62, R78, R79 07-93603-01 Chip Resistor
07360KL
6R8,1206, 0.5W,±1%,RC1206FR-
R22 07-96808-22 chip Resistor
7W6R8L
10KΩ,1206,1/4W,±1%,RC1206FR-
R114, R125, R126, R129 07-91002-02 Chip Resistor
0710KL
33KΩ,1206,1/4W,±1%,RC1206FR-
R8, R18 07-93302-02 Chip Resistor
0733KL
0.0025Ω,2512,1W,±
R9, R42 07-92505-06 chip Resistor
1%,WSL25122L500FEA
R132 07-70103-06 NTC NTC 10K,NTCLE100E3103JB0,±5%
CAPACITORS
C17 26-15051-00 Chip Capacitor 15pJ, NPO, 50V,0603
C28 26-18051-00 Chip Capacitor 18pJ,50V,0603,NPO
100pJ,50V,0603,NPO,C1608C0G1H101
C20, C65, C70, C71 26-10151-00 Chip Capacitor
JT
330pJ,100V,0603,NPO,C1608C0G2A33
C24 26-33112-00 Chip Capacitor
1JT000N
C67, C75 26-10251-10 Chip Capacitor 1nJ,50V,0603,NPO,C1608C0G1H102JT
10nK,50V,0603,X7R,C2012X7R1H103K
C59, C64, C66, C68 26-10351-00 Chip Capacitor
T
C3, C23 26-47251-00 Chip Capacitor 4n7K,50V,0603,X7R
C49, C51 26-10451-10 Chip Capacitor 100nZ, 50V,X7R, 0603
C19, C22, C30, C31, C32, C34, 470nK,25V,0603,X5R,C1608X5R1E474
26-47421-20 Chip Capacitor
C74 KT
C69 26-10511-20 Multilayer Ceramic CAP 1uK,16V,0603,X7R,C1608X7R1C105K
560pJ,100V,0805,NPO
C46, C54 26-56112-01 chip capacitor
CC0805JRNPO0BN561
C47, C48, C52, C53 26-18251-11 Chip Capacitor 1.8nF, 5%, 50V, 0805, NPO
2n2J,50V,0805,NPO,C2012C0G1H222J
C50 26-22251-21 Chip Capacitor
T
C60, C61, C62, C63 26-22511-01 Chip Capacitor 2u2F,16V 0805, X7R
C1, C2, C4, C5, C6, C7, C8, C9,
100nK,100V,X7R,0805,C2012X7R2A10
C16, C33, C41, C42, C43, C44, 26-10412-01 Chip Capacitor
4KT
C45, C76
RD-series, 22uF, 63V, ±20%, 105℃,
C72, C73 06-22061-03 Alu Electrolytic Capacitor
F2.0
RD-series,22uF,100V,±20%, 105℃,
C15, C35 06-22012-04 Alu Electrolytic Capacitor
F2.5
C10, C11, C12, C13, C14, C36,
06-10112-04 Alu Electrolytic Capacitor RD-series, 100uF,100V, F5.0
C37, C38, C39, C40
C21 06-22111-26 Alu Electrolytic Capacitor RD-series, 220uF,16V,±20%,F2.5
C25, C26, C27 25-68412-00  CL23B-100V-684J RA
INDUCTOR
600R/100MHz,0.2A,0805,CBG201209U
L4 08-04601-11 
601T
L1, L6 J22-08318-00 Coil M LCL1 SC8318-145A
L3 J22-08125-00 Coil M LCT5 SC8125-145A,RM10,10uH,28A
POT
R92 09-02201-03 POT 200R,3362P-1-201LF
CONNECTORS
2.54mmPitch,2*18pin ,5u",QHB2251P18
J3 13-12536-04 CON 2X18P MH 2.5mm
CCB12
2.54mmPitch, 5Pin,
J11 13-12505-14 CON 5P MV 2.5mm
CNT-M254-1*5-GS-5.9/3-N
78-090004-0 Insulated Cushion 19×14mm*1.5mm

39
 63-020309-0 Washer Spring GB/T 93 Φ3 blue zinc plated
GB/T848-2002, M3, black zinc plated,
63-010305-2 Washer
ID=3.2mm,OD=6mm
78-238001-0 Insupad Silpad Silica gel,11x10x0.2mm,TO126
78-015002-0 Screw insulator M3 TW-5
Misc and Machanical parts
17-03001-16 Binding Post gold plating,TH>0.06u
17-03001-17 Binding Post gold plating,TH>0.06u
70-375004-0 Main Heatsink 6363 T5
70-375005-1 L Heatsink Right 6363 T5
70-375006-1 L Heatsink Left 6363 T5
67-375004-0 RCA Bracket SECC N5 T=1.6mm,Painting Black
65-375004-0 RCA Bracket SECC N5 T=1.6mm
AL1050, OD=6mm, ID=3.2mm,
70-355013-0 Spacer
H=3.5mm
70-137003-0 Spacer OD=6.3, ID=3.5, H=7.3mm
70-138003-0 AL Spacer OD=6.3,ID=3.5,H=4.5mm
HEAK SINK(6×2) 61-063510-0 Machine Screw MF3×10,black zinc plated
HypexAMP BOARD(4×2) 61-023215-0 self taping screw BTB3×15
HypexAMP BOARD(3×2) 61-023515-0 Machine Screw MB3×15,black zinc plated
BOARD(5×2) 61-023212-0 self taping screw BTB3×12
RCA STAND(1×2) 61-023206-0 Self Tapping Screw BTB3×6,Black zinc plated
76-001002-1 LED Lens 3mm
Led Lens 86-046001-0 LED Lens Gum 3M Double Side Adhesive
PCB-4:Trigger BOARD
CIRCUIT NO. PART NO. DESCRIPTION
01-62204-00 Trigger Board
02-32704-00 SMT

VM1.1,VM1.1,FR-
A16-32704-22 Trigger PCB
4,1.6mm,2Layers,1oz ,TG130,46×19mm

Trigger/LED/Touch Board
A16-32740-22 VM1.1,FR-4,1.6mm ,TG130,110×96mm
ASSM
DIODES
D138 33-14709-09 Zener Diode BZT52C4V7,4.7V,350mW
RESISTOR
470Ω,0603,1/10W,±1%,RC0603FR-
R284 07-94700-00 Chip Resistor
07470RL
6.8KΩ,0603,1/10W,±1%,RC0603FR-
R288 07-96801-00 Chip resistor
076K8L
10KΩ,0603,1/10W,±1%,RC0603FR-
R287 07-91002-00 Chip Resistor
0710KL
CAPACTIOR
C165 26-10451-10 Ceramic Chip Capacitor 100nK,50V,0603,X7R
CONNECTORS
J101 17-02001-55 Con 3.5mm 90° CKX-3.5-36(5P),Black
PB1, PB2 67-114001-0 PCB Terminal SECC-N5 T=1 Ti
SW1 11-04101-30 Tact Switch IT-1102VLC-1160,H=8.35mm 160gf
14-62204-00 Cabel UL1007#26AWG ,L=250mm
PCB-5: Touch BOARD
CIRCUIT NO. PART NO. DESCRIPTION

40
 VM1.1,VM1.1,FR-
A16-32705-22 Touch PCB
4,1.6mm,2Layers,1oz,TG130,50×15mm
VM1.1,FR-
Trigger/LED/Touch Board
A16-32740-22 4,1.6mm,2Layers,1oz, TG130,110×
ASSM
96mm
IC
four button capsense
U101 03-02044-02 CY8CMBR2044-24LKXI
controller
RESISTOR
560Ω,0603,1/10W,±5%,RC0603JR-
R155 07-90561-00 Chip Resistor
07560RL
10KΩ,0603,1/10W,±1%,RC0603FR-
R118 07-91002-00 Chip Resistor
0710KL
R132, R154, R311, R318 07-90000-00 Chip Resistor 0Ω, 0603, ±5%
CAPACTIOR
C111 26-10451-10 Ceramic Chip Capacitor 100nK,50V,0603,X7R
C110 26-10611-20 Ceramic Chip Capacitor 10uF,10V,0603,X5R,±20%
C174 26-22251-00 Ceramic Chip Capacitor 2n2K,50V,0603,X7R
INDUCTOR
742792662,
L100, L105 08-04102-31 Chip Ferrite Bead
1000ohm@100MHz,Imax=600mA
CONNECTORS

CON101 13-21004-04 FPC Connector SMD PH1.0 FPC 4P,JX1.0-B2-4PLT

Copper-Touch PCB 14-32701-00 FFC Cable UL1007#24AWG, Red, L=40mm

PCB-6: LED BOARD
CIRCUIT NO. PART NO. DESCRIPTION
01-32706-00 LED Board
02-32706-00 SMT

VM1.1,VM1.1,FR-
A16-32706-22 LED Board PCB
4,1.6mm,2Layers,1oz ,TG130,50×52mm
Trigger/LED/Touch Board
A16-32740-22 VM1.1,FR-4,1.6mm, TG130,110×96mm
ASSM
DIODES
D150, D163, D164 33-50603-06 SMD LED (RED) SML-310VTT86,Red
D102,D156,D157 33-50603-90 SMD LED (WHITE) WR-PB1608UW-G-M23,White

D103 33-50565-01 LED φ5,Blue&Orange, BL-BB5JC274

TRANSISTORS
Q114 31-00114-01 Digital transistor DTA114EKA
Q109, Q110, Q111, Q112,
31-00114-05 Digital transistor DTC114EKA
Q115,Q116
RESISTOR
220Ω,0603,1/10W,±1%,RC0603FR-
R104, R312, R347, R348 07-92200-00 Chip resistor
07220RL
R320,R321,R322 07-97500-00 Chip Resistor 0603, 750Ω, ±1%
4.7KΩ,0603,1/10W,±1%,RC0603FR-
R102, R103 07-94701-00 Chip Resistor
074K7L
CAPACTIOR
C175 26-10451-10 Ceramic Chip Capacitor 100nK,50V,0603,X7R
C176 26-22511-30 Ceramic Chip Capacitor 2.2uK,10V,0603,X5R,CL10A225KP8NN
INDUCTOR

41
 742792662,
L104 08-04102-31 Chip Ferrite Bead
1000ohm@100MHz,Imax=600mA

CONNECTORS

CON108 13-21004-04 FPC Connector SMD PH1.0 FPC 4P ,JX1.0-B2-4PLT

2mmPitch,2*4Pin,CNT-B200-2*4-GS-
CON107 13-22008-05 IDC connector
2.8-N

MCU PCB-Touch PCB 14-32704-10 FPC Cable 4Pin,1.0mmPitch,L=160mm,coplanar

MCU PCB-Touch PCB 14-32708-20 Cable CNT-C200-8-260 FC

PCB-7: SMPS BOARD
CIRCUIT NO. PART NO. DESCRIPTION

VM1.0,FR-
A16-32707-21 Bare PCB SMPS 4,1.6mm,2Layers,2oz, TG130,200×
126mm
DIODE
D6, D7, D12, D25, D26, D30,
33-20316-01 High speed Diode BAS316
D31, D33, D34, D39, D41, D43
D23, D24, D28, D29, D37, D38,
33-40054-02 Schottky Rectifier Diode BAT54J
D40
D5, D9, D14, D16, D21, D22,
33-40056-01 High-speed double diode BAW56W-7-F
D42
D5, D9, D14, D16, D21, D22,
or33-40056-00 High speed Diode BAW56W SOT323
D42
D11 33-20020-00 Super Fast Rectifier Diode BYG20J-E3/TR3
Surface Mount Schottky
D8, D35, D44 33-20016-01 SS16 SMA
Barrier Rectifier
D18, D19, D20 33-20220-01 Ultrafast Power Rectifier MURA220T3G
Transient Voltage
D10 33-00200-01 P4SMA200A
Suppressor
D27, D32, D36 33-11200-05 Zener Diode PDZ12B 12V 0.4W SOD323
D17 33-11500-05 Zener Diode PDZ15B 15V 0.4W SOD323
D15 33-15609-06 Zener Diode PDZ5.6B 5.6V,0.4W,SOD323
D13 33-21540-01 Schottky Rectifier Diode 15MQ040NTRPBF
D1, D2, D3, D4 33-20600-01 Ultrafast Rectifier Diode BYT79X-600 TO-220F
TRANSISTORS
T11, T17, T19, T20, T22, T45 31-80716-00 Transistor BC807-16 PNP
T25, T30, T43 31-00807-40 Transistor BC807-40W PNP
T21, T46 31-00817-16 Transistor BC817-16 NPN
T26, T29, T40 31-00817-01 NPN Transistor BC817-40W, 45V 500mA
T7, T8, T10, T13, T14, T18, T23,
T31, T33, T34, T35, T38, T39, 31-00846-02 Transistor BC846BW SOT323
T41, T42
T9, T12, T15, T16, T27, T28, T32,
31-00856-03 Transistor BC856BW SOT323
T37, T44
T24, T36 31-00056-01 Transistor BCP56 SOT223
IC
U5 03-00494-02 Power controller IC TL494CDRG4, SO16
Dual Differential
U7 03-00393-03 LM393DR
Comparator
Multi-Channel Full-Pitch
U3, U4 03-00827-03 Phototransistor LTV827S
Optocoupler
U2, U6 03-00431-05 Shunt Regulator TL431CDBZR

42
 Self-Supplied Monolithic
U1 03-01014-01 NCP1014ST65T3G
Switcher
RESISTORS
Power Metal Strip Chip 0.018Ω,2512,2W,±
R69 07-91806-26
Resistor 1%,WSL2512R0180FEA18
R46, R47, R48 07-91209-00 Chip Resistor 12Ω,0603,1/10W,±1%,
R10, R17, R29, R35, R40, R65, 10Ω,0603,1/10W,±1%,RC0603FR-
07-91009-00 Chip resistor
R74, R78, R121 0710RL
100Ω,0603,1/10W,±1%,RC0603FR-
R63, R117 07-91000-00 Chip Resistor
07100RL
220Ω,0603,1/10W,±1%,RC0603FR-
R15, R49 07-92200-00 Chip resistor
07220RL
180KΩ,0603,1/10W,±1%,RC0603FR-
R95, R96, R100 07-91803-00 Chip resistor
07180KL
R11, R13, R16, R19, R30, R36,
1KΩ,0603,1/10W,±1%,RC0603FR-
R41, R53, R61, R62, R64, R71, 07-91001-00 Chip Resistor
071KL
R82, R90, R118
1.2KΩ,0603,1/10W,±1%,RC0603FR-
R87? 07-91201-00 Chip Resistor
071K2L
R7, R14, R57, R81, R83, R88, 2.2KΩ,0603,1/10W,±1%,RC0603FR-
07-92201-00 Chip Resistor
R103, R124 072K2L
3.3KΩ,0603,1/10W,±1%,RC0603FR-
R80 07-93301-00 Chip Resistor
073K3L
R8, R12, R43, R44, R45, R66,
10KΩ,0603,1/10W,±1%,RC0603FR-
R70, R72, R84, R91, R94, R102, 07-91002-00 Chip Resistor
0710KL
R104, R107, R108, R109, R115
18KΩ,0603,1/10W,±1%,RC0603FR-
R75 07-91802-00 Chip Resistor
0718KL
22KΩ,0603,1/10W,±1%,RC0603FR-
R5, R9, R60 07-92202-00 Chip resistor
0722KL
R6, R20, R21, R22, R23, R24,
47KΩ,0603,1/10W,±1%,RC0603FR-
R27, R31, R52, R56, R59, R76, 07-94702-00 Chip Resistor
0747KL
R77, R89, R92, R105
47KΩ,0805,1/8W,±1%,RC0805FR-
R4, R26 07-94702-01 Chip Resistor
0747KL
R68, R85, R93, R97, R101, 100KΩ,0603,1/10W,±1%,RC0603FR-
07-91003-00 Chip resistor
R106, R111, R112, R113, R114 07100KL
220KΩ,0603,1/10W,±1%,RC0603FR-
R58 07-92203-00 Chip Resistor
07220KL
5.6KΩ,0603,1/10W,±1%,RC0603FR-
R38 07-95601-00 Chip Resistor
075K6L
1MΩ,0603,1/10W,±1%,RC0603FR-
R32, R33, R67, R73 07-91004-00 Chip Resistor
071ML
R50, R51, R54, R55, R122, 1MΩ,1206,1/4W,±1%,RC1206FR-
07-91004-02 Chip Resistor
R123 071ML
12Ω,1206,1/4W,±1%,RC1206FR-
R25 07-91209-02 Chip resistor
0712RL
390KΩ,1206,1/4W,±1%,RC1206FR-
R110, R116, R119, R120 07-93903-02 Chip resistor
0712RL
R2, R3, R18, R28, R34, R37, 68Ω,1206,1/4W,±1%,RC1206FR-
07-96809-02 Chip Resistor
R39, R42, R79, R86, R98, R99 0768RL
R1 A07-70060-00 Thermistor 10Ω @25℃, ±25%, CL-60
CAPACITORS
C41, C50, C51, C52, C59, C66,
26-10251-00 Ceramic Chip Capacitor 1nK,50V,0603,X7R
C67

43
C35, C36, C40, C45, C46, C53,
C57, C61,C63, C68, C73, C74, 26-10451-10 Ceramic Chip Capacitor 100nK,50V,0603,X7R
C77, C78
C47, C55, C56, C58, C60, C65 26-10511-20 Ceramic Chip Capacitor 1uK,16V,0603,X7R,C1608X7R1C105K
220nK,25V,0603,X7R,C1608X7R1E224
C44, C71 26-22421-00 Ceramic Chip Capacitor
KT
220pK,500V,0805,X7R,0805B221K501N
C38, C43, C49, C54, C69, C72 26-22152-01 Ceramic Chip Capacitor
T/HCM0805X7RR221K501PT
C64 26-47151-00 Ceramic Capacitor SMD 470pJ,50V,0603,NPO
180pJ,100V,NPO,0603,0603CG181J101
C42 26-18112-00 Ceramic Chip Capacitor
NT
High Voltage MLC Chip 10nK,630V,X7R,1206,1206CC103KAZ1
C48, C70, C75, C76 26-10362-12
Capacitor A
100nK,100V,X7R,0805,C2012X7R2A10
C37, C39 26-10412-01 Ceramic Chip Capacitor
4KT
Hign Voltage Cermatic
C15, C16, C24 A05-10242-00 CT81-400VAC-08b-2E4-102M-YA
Capacitor
Interference Suppression MPX,220nF,275VAC,±
C8 A25-22422-09
Capacitor 10%,X2,PX224K3ID39L27
Interference Suppression
C7, C10, C12, C14, C17 A25-47422-00 MKP62/MPX,0.47uF, 275V, 10%,
Capacitor
HE-series,1000uF,200V,±
C1, C2, C3, C4, C5, C6 06-10222-02 Alu Electrolytic Capacitor
20%,30*35mm,105 ℃
C28 06-10131-07 Alu Electrolytic Capacitor RD-series,100uF,35V,±20%,105 ℃,F2.5
C23, C31 06-15211-02 Alu Electrolytic Capacitor RD-series,1500uF,10V, ±20%,105 ℃
C18, C19, C29, C30, C33, C34 06-22112-00 Alu Electrolytic Capacitor RD,220uF,100V, ±20% 12.5X25MM
C11, C20, C21, C22, C25, C26,
06-22131-10 Alu Electrolytic Capacitor RD-Series 220uF,35V,±20%,F3.5
C27, C32
RD-series, 22uF, 63V, ±20%, 105℃,
C9, C13 06-22061-03 Alu Electrolytic Capacitor
F2.0
INDUCTOR
BLM21AG331SH1D, 330R/100MHz
L10, L11, L12, L13 08-04331-01 Ferriet Bead
1.5A,0805
L5 08-02065-00 Ferriet bead 65R/100MHZ 7A,BL01RN1A1F1J
L1, L2, L3, L4, L6, L7, L8, L9 J22-08318-00 Inductor SC8318-145A,1uH/8A
MOSFET
T3, T4, T5, T6 31-06120-00 N-ch MOSFET FDP61N20 TO220
T1, T2 31-32503-00 MOSFET SPW32N50C3
TRANSFORME
R
TR1, TR3 J08-02202-00 COMMON INDUCTOR SC7619-145A,2mH,8A
TR4 J22-08191-00 Transformer SC8191-145A
TR5 J22-07856-02 Transformer SBY SC7856-145A REV.G
TR2 JA22-08887-01 Transformer SC8887-145A
TR2 86-000202-0 3M Adhesive #1350 or CT-280,W=34mm,BLK
TR2 86-000203-0 3M Adhesive #1350 or CT-280,W-16mm ,BLK
RELAY
5mmPitch, 2Pin,
K1 J13-15002-01 Connector
PR01502VBVC(31027102)
5mmPitch, 2Pin,
K1 J13-25002-03 Connector
RP02502HBWC(31107102)
K2 12-01102-04 RELAY RT314012F,12V 1x16A
CONNECTOR
J3 13-22510-23 Connecter CNT-1132-10
3.96mmPitch,3Pin,Pull the middle
J1 13-23903-16 Connecter
pin,VH-3A2

44
J1 or 13-23903-07 Connecter 2P MV 8mm PCB JST
2X3P MV 6.2mm PCB JST,JST VL-
J2 13-26206-00 Connecter
series
FUSE
F1 A20-12123-01 FUSE 0215012.MXEP,T12AH/250V
F1 A78-000060-1 Heat Shrinking Tube Φ6, CB-HFT
MISC and Mechanical
Mechanism parts
LEFT SPACER 85-320002-0 Nylon screw M3-12N
RIGHT SPACER 61-023512-1 Machine Screw MB3X12 ,Blue zinc plated
PRESPACER/2 61-063520-1 Machine Screw MF3X20, Blue zinc plated
61-063508-1 Machine Screw MF3×8,Blue zinc plated
61-063506-1 Machine Screw MF3×6,Blue zinc plated
TNSTALL PCB 70-355002-0 Connection Heatsink 6063,black oxide
MECH19, MECH20, MECH21,
MECH22, MECH23, MECH24,
66-355001-0 Heatsink Spring Clip Stainless steel
MECH25, MECH26, MECH27,
MECH28
70-355003-0 Plate Heatsink AL1050A,T=3mm
78-355003-0 Insupad HF300P1.0, 55×30mm
78-355001-0 Insupad 49X55X0.5mm, 5W/Mk
78-355002-0 Insupad 58X55X0.5mm,5W/Mk
63-020309-0 Washer Spring GB/T 93 Φ3 Blue zinc plated
63-010308-1 Plain Washer φ3,0.8mm
62-010302-0 NUT M3 IIN934 M3
78-251006-0 Insupad Silicon(Grey),20X26mm
86-251001-0 tape adhesive copper W=19 mm(3M 1181 L=16.5m )
21-06181-00 Link(φ0.6) L=18mm
MECH14, MECH18 85-138102-0 Nylon Spacer 3-10mm Nylon
MECH3, MECH4 85-138103-0 Nylon Spacer 3-7.5
85-355001-0 Threaded Spacer TPS-10
62-110302-0 Plastic NUT Nylon66,M-3
94-355008-0 PCB Voltage Label 39x13mm,White PET
PCB-8: SMPS STB BOARD
CIRCUIT NO. PART NO. DESCRIPTION
A16-62208-21 SMPS STB PCB VM1.0,FR-4,1.6mm,2Layers,2oz, TG130

DIODES
D301 33-30062-00 BRIDGE RECTIFIER B6S, 0.8A 600V
D306 33-44148-17 Switch Diode 1N4148W-NR
D304 33-40321-00 Switch Diode BAS321
D305 33-20036-00 Schottky Rectifier Diode SS36B
DW301 33-12000-03 Zener Diode SMD 20V, 3W, BZG03C20
D302 33-20020-00 Super Fast Rectifier Diode BYG20J-E3/TR3
Transient Voltage
D303 33-00200-01 P4SMA200A
Suppressor
ICS
IC302 03-00431-05 Regulator TL431CDBZR
OP301 A03-00817-03 Photo Coupler PC817B

45
 Automatic X Cap
IC303 03-00017-01 CAP017DG-TL SO-8 CAP017DG-TL
Discharge IC
IC301 03-00274-00 Power controller IC TNY274PN
RESISTORS
10Ω,0805,1/10W,±1%,RC0805FR-
R301 07-91009-01 Chip resistor
0710RL
100Ω,0805,1/8W,±1%,RC0805FR-
R306 07-91000-01 Chip resistor
07100RL
220Ω,0805,1/8W,±1%,RC0805FR-
R311 07-92200-01 Chip resistor
07220RL
R307 07-91001-01 Chip resistor 1KΩ,0805,1/8W,±1%,RC0805FR-071KL
2.2KΩ,0805,1/8W,±1%,RC0805FR-
R309, R310 07-92201-01 Chip resistor
072K2L
10KΩ,0805,1/8W,±1%,RC0805FR-
R308 07-91002-01 Chip resistor
0710KL
22KΩ,0805,1/8W,±1%,RC0805FR-
R305 07-92202-01 Chip resistor
0722KL
4.7KΩ,0805,1/8W,±1%,RC0805FR-
R312 07-94701-01 Chip resistor
074K7L
180KΩ,1206,1/4W,±5%,RC1206JR-
R302, R304 07-90184-02 Chip resistor
07180KL
TH301 A07-70080-01 NTC SCK08082MSY, 8Ω 2A
ZV301 A07-70471-00 TVS 471KD14
CAPACTIOR
100pJ,50V,0805,NPO,C2012C0G1H101
C309 26-10151-01 Chip capacitor
JT
C305, C306, C307, C308 26-10451-01 Ceramic Chip Capacitor 100nZ,50V,0805,Y5V
TRANSISTORS
Q301 31-02878-00 transistor 2SC2878
CAPACTIOR
C301 06-10042-00 Alu Electrolytic Capacitor CD11H,10uF,400V,±20%,105 ℃,F5.0
C302 06-10051-02 Alu Electrolytic Capacitor CD263, 10uF, 50V, ±20%, Pitch=2.5mm
C304 06-10211-05 Alu Electrolytic Capacitor CD263X,1000uF,10V,±20%,105 ℃,F5.0
C303 06-10211-08 Alu Electrolytic Capacitor CD287,1000uF,16V,±20%,105 ℃,F5.0
Interfernece Suppression MPX,0.1uF/275V,13mm*6mm,10%,Pitc
CX303 A25-10422-07
Cap h=10mm
Interfernece Suppression
CX302 A25-47422-02 MKP62, 470nF, 275VAC, X2, ±10%
Cap
Interfernece Suppression
CX301 A25-10522-02 MKP62, 1UF, 275VAC, X2, ±20%
Cap
Hign Voltage Cermatic 1nF, 400V(X1), 250V(Y1), ±20%
CY301, CY303, CY302 A05-10242-00
Capacitor CT81-400VAC-08b-2E4-102M-YA
INDUCTOR
L301 08-02339-00 Inductor 3.3uH
L304 08-05551-01 Inductor HJ-M22-PFC-L
L302, L303 22-00025-09 common mode line chokes LE-T25M, ≥8mH
RELAY
K301 A12-03101-02 POWER RELAY 832A-1A-C-BH DC5V
FUSE
F301 A20-12122-04 FUSE 5ET-013HA,T1.25A/250V
CONNECTORS
P301, P302 32-26308-06 Connecter KY250
J302 13-22503-00 Connecter XHB 2.5A-3A
LD7.92A-2A, (VH 3.96A-3A, Pull the
J303 13-23903-01 Connecter
middle pin)

46
 TRANSFORME
R
HJ-M22/M27-EE16,Black tape
T301 A22-00016-38 Transformer

CONNECTORS
A11-01201-03 Rocker Switch 1552.3112
A20-12103-00 Fuse 0618010.XP,T10AL/250V
A17-07103-08 AC Inlet
UL1672#18AWG,L=100mm,Add the
Chassis TO AC INLET A14-26501-01 1PIN CBALE
circular
19-22008-00 Ferrite Ring HJ-2208,T22×14×8 10K,Ferrite Ring
L/N - STANDBY PCB A14-62202-00 WIRES UL1672#16AWG, , L=400mm
FUSE SEAT-SWITCH A14-33201-01 1PIN CBALE L=70mm
POWER SOCKET
A14-32201-04 Wire UL1672#16AWG, L=70mm
-SWITCH
STANDBY PCB－SMPS A14-32702-01 WIRES UL1672#18AWG ,L=250mm
STANDBY PCB-MCU PCB 14-62203-01 wire UL1007#22AWG, L=300mm
SMPS-MCU PCB 14-32706-00 Wire UL1015#16AWG/18AWG, L=130mm
SMPS-MCU PCB 14-62210-00 Wire UL2468#24AWG,L=180mm
ACCESSORIES
A20-12103-00 Fuse 0618010.XP,T10AL/250V
LP-34 & H05VV-F 3×1.00mm2 6' BLK &
JA15-16250-00 AC Cord
LS-60
or A15-10230-20 AC Cord T973-C
LP-31 & SJT 14/3C BLK L=1800 & LS-
JA15-16120-12 AC Cord
13
AP-003 & SJT 14/3C BLK L=2000 & AP-
or A15-16120-11 AC Cord
005
or A15-16120-10 AC Cord T973-AH
METAL PARTS
70-375910-0 Fascia Assy
(70-375008-0A) Center Front Fascia AL 6063-T5
(70-375007-0A) Left Front Fascia AL 6063-T5
(70-375009-0A) Right Front Fascia AL 6063-T5
(70-375010-0) Back Fascia AL 6063-T5,
Left Front Fascia（4），Right
61-224510-1 Hex Screws GB/T70.1, HM4×10, nickel plating
Front Fascia（4）
Center Front Fascia（4） 61-063506-0 Machine Screw MF3×6,Black zinc plated
Center Front Fascia（4） 61-024208-0 Self Tapping Screw BTB4×8,Black zinc plated
70-375002-0 Left Side Panel AL 6063-T5
70-375003-0 Right Side Panel AL 6063-T5
Stainless Steel, T=0.5mm,Black
67-267005-0 Vent sheet
Painting
70-267007-1 Main Top Cover 6063 T5

70-267008-0 Second Top Cover Al1050 T=3.0mm

67-267004-0 Perf Sheet SPCC, T=0.5mm,Black Painting

SECC-N5 T=1.0mm
67-375005-0 Connector Bracket

65-375005-0 Connector Bracket SECC-N5 T=1.0mm

67-375003-0 Fascia Connect Sheet SECC N5 T=1.2mm，Painting Black
65-375003-0 Fascia Connect Sheet SECC N5 T=1.2mm
67-355011-0 Logo Clamp SECC N5 T=1mm,Painting Black
65-355011-0 Logo Clamp SECC N5 T=1mm
67-355012-0 Logo Clamp SECC N5 T=1mm,Painting Black

47
 65-355012-0 Logo Clamp SECC N5 T=1mm
67-375001-1 Chassis SECC-N5 T=1.2mm
65-375001-1 Chassis SECC-N5 T=1.2mm
SECC-N5 T=1.0mm
67-375002-0B Rear Panel

SECC-N5 T=1.0mm
80-375002-0 Rear Panel

65-375002-0 Rear Panel SECC-N5 T=1.0mm

SECC-N5 T=1.0mm
67-375012-0A Rear Panel

SECC-N5 T=1.0mm
80-375002-0 Rear Panel

65-375002-0 Rear Panel SECC-N5 T=1.0mm

J71-267002-0 Masters II Feet

71-267003-0 Feet Shoe Assy

J71-267903-0 Masters II Feet Shoe

78-267001-0 Feet PAD Poron MX-48HF BLACK
J71-355001-0A NAD Logo
96-355001-0A Touch Key Cap 18*6*2
69-355002-0 Touch Key Copper plate T2Y2 T=0.2mm
86-355001-0 Adhesive tape 3M 9448,T=0.1mm
FASTENERS
61-273308-1 Self Tapping Screw M2.9×18×8
AMP Heatsink (4×2) 61-023208-0 self taping screw BTB3×8
Hypex Power Module（6） 61-023508-0 Machine Screw MB3×8
STB BOARD(4) 61-023506-1 Machine Screw MB3×6
Touch Key Board（2），Logo
61-023206-0 Self Tapping Screw BTB3×6
Clamp（4）
Fascia Connect Sheet
61-033208-0 Self Tapping Screw BTP3×8
（4）,Rear Panel（4）
Vent sheet（12） 61-022205-6 Self Tapping Screw BTB2.6×5
MCU Board（5），Connector
Bracket(4), RCA BRACKET 61-023106-0 self taping screw STB3×6
（2），Trigger Board(2),
Loam Cake(15), Logo PCB(2),
61-023506-0 Machine Screw MB3×6
Fascia Connect Sheet(4)
Loam Cake（15） 63-010309-5 Plain Washer Ф3×Ф9.5mm, 8mm
Loam Cake(7) J61-234510-1 Machine Screws M4X10,
Chassis（14） 61-024506-0 Machine Screw MB4×6
AC INLET(2) 61-073208-0 Self Taping Screws BT03X8
Grouding (1) 62-010402-0 Nut GB6170-86, M4
Grouding (1) 63-020411-0 Spring Washer GB93-87 φ4
Grouding (1) 63-010408-0 Plain Washer GB97.1-85 φ4
62-010402-0 Nut M4
63-040408-0 Spring Washer M4 GB862.2 4
71-003002-0 Grd.Post Cap
160 HPB59-1 71-003001-1 Grd.Post Bolt
63-010408-3 Plain Washer GB/T97.1, ?4, L3
ACCESSARIES
85-046001-0 Wire Saddle Side Entry WCL-4
84-001003-0 Cable Tie YJ-100, Black
IEPE Foam，Black,
79-355001-0 Shock Absorber Pad
318mmx12mmx0.5mm
A78-000350-0 HEAT SHRINKING TUBE Φ35, CB-HFT

48
 79-158012-0 EVA Foam EVA Foam 162X15mm ，T=1mm
79-375002-0 LED Board Foam EVA,black,50x52mm,T=1mm
PACKING

88-375001-0A Carton Box 547*495*219mm

N88-375003-1 Paper Corner 50*50*5mm,L=197mm

89-355901-0 Cushions Assy

88-355005-0A Paper Formed Box

88-355006-0 Cushion First Layers BC, 525*480*7mm

88-355007-0 Cushion Second Layers BC, 525*480*7mm

88-355008-0 Cushion Third Layers BC, 尺寸:525*480*7mm

88-355009-0 Cushion Forth Layers 525*480*7mm

88-355010-0 Cushion Last Layers 525*480*7mm

89-355001-0 Main Pulp 523mmX478mmX92.5mm

89-355003-0 Accessory Pulp 286mmX180mmX47mm

89-355004-0 Shoe Cover Pulp 118mmX111mmX14mm

88-355003-0A Cables Box 306mmX187mmX52mm

NAD Logo 90-355002-0 woven bag L620×W530,black

88-351006-0A accesory box

88-355004-0A Cleaning Cloth bag L160×W110

90-355001-0 Cleaning Cloth 150mmx150mm

30-49622-00 USB 说明书 2G

37-00200-01 USB Disk 2G ,L-008

30-49623-00 Quick Setup Guide 157g,370X287mm

30-05000-00 Desiccant 50g 90×110,

30-51500-01 Guarantee Card 210X148mm

Rear Panel(1), Carton
94-375003-0 Serial No. Label 53×10mm(selfcommand)
Box(2),Traveler(1)
53×10mm,base color:Pantone cool gray
86-005310-0 Copperplate Label
6C
Carton Box(2) 94-375006-0 Product Barcode Label 40×30mm(selfcommand)
40×30mm,base color:Pantone cool gray
86-004030-0 Copperplate Label
6C
Carton Box(2) 94-375016-0 Product Barcode Label 40×30mm(selfcommand)

49
 40×30mm,base color:Pantone cool gray
86-004030-0 Copperplate Label
6C
94-054002-0 Grouding Label φ10

50
 M22 Amp Module L M22 Amp Module R

S022

S022 S022

S022 S022
A006
S022
A001
A005
A001

A005 S023 S024

S023

S023 S023
S024
S024
S024
A006 S003
S023
A002
A004

S003 A004
A007
A002
A007
A011
A008
A003 A007

S021 A009
S021
A010
S021
A009 A007
A008 A008 A008
A007
A009 A008 S021
A007 A008 A007 A010 A007

REF.N0 Part No. Description Qty. REF.N0 Part No. Description Qty.
A001 01-62202-00 AMP Board 2 A010 78-015002-0 Screw insulator M3 4
A002 01-62203-00 NC400 OEM Board 2 A011 70-375005-1 L Heatsink Right 1
A003 70-375006-1 L Heatsink Left 1
A004 70-375004-0 Main Heatsink 2
A005 67-375004-0 RCA Bracket 2 S003 61-023206-0 Self Tapping Screw BTB3X6 2
A006 76-001002-1 LED Lens 2 S021 61-063510-0 Machine Screw MF3X10 12
A007 70-138003-0 AL Spacer 12 S022 61-023212-0 Self Tapping Screw BTB3X12 10
A008 70-137003-0 AL Spacer 8 S023 61-063520-1 Self Tapping Screw BTB3X15 8
A009 70-355013-0 AL Spacer 4 S024 61-023515-0 Machine Screw MB3X15 6

5
 M22 Packing Exploded View

11
13
12

14
6
10

15

5 9
REF.N0 Part No. Description Qty.
1 88-375004-0A Shipping Box 1
8
2 88-375001-0A Carton Box 1
3 3 89-355901-0 Cushions Assy 2
4 88-375003-1 Paper Corner 4
5 00-62200-10 M22 Unit (AH Version) 1
7 00-62200-20 M22 Unit (C Version) 1
4
6 90-355002-1 Woven Bag 1
7 88-355003-0A Accessory Box 2
8 88-267002-0 Accessory Box Sheet 1
4
9 88-351006-0A Cable Box 1
10 89-355003-0 Accessory Pulp 1
11 89-355004-0 Shoe Cover Pulp 1
12 J71-267903-0 Masters II Feet Shoe 4
78-267001-0 Feet PAD 4
13 30-49622-01 Instruction Manual 1
14 88-355004-0A Cleaning Cloth bag 1
2 90-355001-0 Cleaning Cloth 1
15 JA15-16250-00 AC Cord C:1
or A15-10230-20 AC Cord C:1
JA15-16120-12 AC Cord AH:1
or A15-16120-11 AC Cord AH:1
1
or A15-16120-10 AC Cord AH:1

5
 M22 SMPS Exploded View

P004

P005

P001
P003

S030
P005

P006 S028

S031 S025

S030
S027

S026

S029

P006

P007

S025 P002

S029

REF.N0 Part No. Description Qty.

P001 01-62207-10 SMPS BOARD (AH) AH:1
01-62207-20 SMPS BOARD ( C) C:1
P002 70-355003-0 Plate Heatsink 1
P003 70-355002-0 Connection Heatsink 1
P004 66-355001-0 Heatsink Spring Clip 10
P005 85-138103-0 Nylon Spacer 2
P006 85-138102-0 Nylon Spacer 2
P007 85-355001-0 Threaded Spacer 1

S025 61-063506-1 Machine Screw MF3X6 4

S026 61-063508-1 Machine Screw MF3X8 4
S027 85-320002-0 Nylon screw M3-12N 1
S028 61-023512-1 Machine Screw MB3X12 1
S029 61-063520-1 Machine Screw MF3X20 2
S030 62-110302-0 Plastic NUT,Nylon66,M-3 1
S031 62-010302-0 NUT M3 2

5
 T001
S014

S014
S014

T002

T003 S008
R004
S006 S006
R005 S016 S002
R007
R006
S015 S004 R002
C002
S004 R003
S004
S015
S015 S010

S004 S006
S001 S015

C010 S002
S008 C012
S011 S006 S011
C006 R008 R004
C004 S005

5
C011 S020 S019
C005 C014 S008
S008 S005 S020
S001 R005
S018
S011 R001 S011
S003 C007 S017
F010
S012
S013
S003

C001
F007
M22 ASSY EXPLODE VIEW

S006
F006
S007
C008 S009
S007
F008 C013 C003
F005 C009 S006
F009 S006
F011 S009 C007

F002 S012
S013 C008 S008

F003 C004 S011

F001 C009

F004
 M22 EXPLODED VIEW PARTS LIST

REF.NO PART NO. DESCRIPTION Qty. REF.NO PART NO. DESCRIPTION Qty.

C001 67-375001-1 Chassis 1 R002 A11-01201-03 Rocker Switch 1

C002 70-375002-0 Left Side Panel 1 R003 A17-07103-08 AC Inlet 1

C003 70-375003-0 Right Side Panel 1 R004 17-03001-16 Binding Post 2

C004 67-375003-0 Fascia Connect Sheet 2 R005 17-03001-17 Binding Post 2

C005 67-267005-0 Vent sheet 2 R006 71-003002-0 Grd.Post Bolt 1

C006 67-375005-0 Connector Bracket 2 R007 71-003001-1 Grd.Post Cap 1

C007 J71-267002-0 Masters II Feet 4 R008 01-62204-00 Trigger Board 1

C008 J71-267903-0 Masters II Feet Shoe 4

C009 78-267001-0 Feet PAD 4 T001 70-267007-1 Main Top Cover 1

C010 01-62290-00 AMP Board Module (Left) 1 T002 70-267008-0 Second Top Cover 1
C010 01-62280-00 AMP Board Module (Right) 1 T003 67-267004-0 Perf Sheet 1

C012 01-62201-00 MCU Board 1

C013 01-62207-10 SMPS Board(AH) 1 S001 61-022205-6 Self Tapping Screw BTB2.6x5 12

01-62207-20 SMPS Board(C) 1 S002 61-273308-1 Self Taping Screws M2.9×18×8 4

C014 01-62208-00 SMPS STB BOARD 1 S003 61-023206-0 Self Taping Screws BTB3×6 6

S004 61-373506-0 Machine Screw M3×6 21

S005 61-023506-1 Machine Screw M3×6,Ni 4

F001 70-375010-0 Back Fascia 1 S006 61-023106-0 Self Taping Screws STB3×6 13

F002 70-375007-0A Left Front Fascia 1 S007 61-023208-0 Self Taping Screws BTB3×8 8

F003 70-375008-0A Center Front Fascia 1 S008 61-033208-0 Self Taping Screws BTP3×8 8

F004 70-375009-0A Right Front Fascia 1 S009 61-023508-0 Machine Screw M3×8 6

F005 J71-355001-0A NAD Logo 1 S010 61-073208-0 Self Taping Screws BTO3×8 2

F006 67-355011-0 Logo Clamp 1 S011 61-024506-0 Machine Screw M4×6 14

F007 67-355012-0 Logo Clamp 1 S012 61-024208-0 Self Taping Screws BTB4×8 4

F008 96-355001-0A Touch Key Cap 1 S013 61-224510-1 Hex Screws HM4×10,Ni 8

F009 69-355002-0 Touch Key Copper plate 1 S014 J61-234510-1 Machine Screw M4×10 7

F010 01-32706-00 LED Board 1 S015 63-010309-5 Plain Washer Ф3×Ф9.5mm 15

F011 01-32705-00 Touch Board 1 S016 63-010408-3 Plain Washer GB/T97.1, Ф4,Ni 1

S017 63-010408-0 Plain Washer GB/T97.1, Ф4 1

S018 63-020411-0 Spring Washer GB93-87, Ф4 1

R001 67-375002-0B Rear Panel(AH) 1 S019 63-040408-0 Tooth Washer GB862.2 4, Ф4 1

67-375012-0A Rear Panel(C) 1 S020 62-010402-0 Nut 2

55