Generator Controller Manual

GTR-17
Generator Controller
Manual
Tres Arroyos 329 - Haedo (1706)

Buenos Aires - Argentina
: (54-11) 4926-0600 / 4483-3630

: (54-11) 4627-3500
E-mail: cram@speedy.com.ar
Web Site: www.cramelectro.com
GTR-17
Table of Content
1. Controller Description...................................................................................................2
2. Profile ...........................................................................................................................2
3. Back Panel Function Description..................................................................................3
4. Case Dimension ...........................................................................................................4
5. Specifications ...............................................................................................................5
6. Controller Wiring Example............................................................................................6
Ver.:V1703 1
GTR-17
1. Controller Description
GTR-17 is low cost but multi-function diesel engine generator controller. It applies with
3 buttons and provides 3 kinds of operation mode: Manual, Auto, Off. No special training is
required due to the easy operation. Fault protection includes: Emergency stop, Over speed,
High water temperature, Low oil pressure, and Over crank. GTR-17 also displays the low
battery voltage warring, and indicates the running status and power status.GTR-17 equips
with high firm continental-type terminal that provides easy plug in and removal.
Furthermore, GTR-17 has 10 pins Dip switch for adjusting parameter according to system
requirements, and make it not only reducing stock but also meeting the various system
specifications. GTR-17 build-in 5 output powers relays which perform high power capacity
reach to 5 Amp (DC) that saves the wring for connection with extra power relays. No matter
in function, protection or operation performance. GTR-17 is your best choice.
2. Profile
Fig. 17 Front Panel
A、LED Indication
Emergency / Auxiliary Shutdown
Low Battery Warning
Over Speed Shutdown
High Water Temperature Shutdown
Low Oil Pressure Shutdown
Over Crank
Run
Power
B、Operation Buttons
ATS
Auto Start function by detect ATS terminal 12 grounded.
Off
Stop running engine or stand still / Reset Alarm.
Manual
Manual start engine directly.
Ver.:V1703 2
GTR-17
3. Back Panel Function Description
Fig. 2 GTR-17 Controller Back Panel

E u r o p i u m
Number Description Code
1 Input power (Battery +) ++
2 Ground (Battery -) GND
3 Output starter relay Motor
4 Output fuel valve relay Valve
5 Output alarm relay Alarm

S t y l e
6 Output stop relay Stop
7 Output Idle/Pre-heat relay Pre-Heat
8 Charge fire point Charge
9 Aux. switch shutdown Em.Stop

C o n n e c t o r
10 Input , High water temp. switch H.W.T.
11 Input, Low oil press. switch L.O.P.
12 Input , Auto start ATS
13 Input , Frequency detect terminal F.D1
14 Input , Frequency detect terminal F.D2
List 1 GTR-17 Terminal
Ver.:V1703 3
GTR-17
A、Dip switch settings function

Pin 1 & Pin 2：Valve on to stop engine timer
Valve on stop engine
Pin1 Pin2
delay
OFF OFF 5 sec
ON OFF 10 sec
OFF ON 15 sec
ON ON 20 sec
List 2 Stop Period

Pin3：System frequency【ON：50Hz；OFF：60Hz】
Pin4：Escape motor by oil pressure switch【ON：Enable；OFF：Disable】
Pin5：Pressure switch type【ON：Normal Open；OFF：Normal Close】
Pin6：Idle / Pre-heat output delay time【ON：10（120）Sec；OFF：1（300）Sec】
Pin7：Low DC Volt【ON：10.5VDC；OFF：21VDC】
Pin8 & Pin9 Cooling time：
Pin8 Pin9 Cooling time
OFF OFF 0 Sec
ON OFF 60 Sec
OFF ON 150 Sec
ON ON 300 Sec
List 3 Cooling Time

Pin10：Idle / Pre-heat Function Select【ON：Idle；OFF：Pre-heat】
4. Case Dimension
Fig. 3 GTR-17 Case Dimension of Back View Fig. 4 GTR-17 Case Dimension of Side View
Ver.:V1703 4
GTR-17
5. Specifications
DC supply：
8~36 VDC
Power Consumption：
Max.5 W
Measuring Frequency：
0～75 Hz (min AC Volt.25V ; max AC Volt. 300V)
Relay Output ：
Start output：5A
Valve output：5A
Idle / Pre-heat output：5A
Alarm Output：5A
Stop output：5A
Ambient Temperature Range：

-10 ℃ ～ 60 ℃
Dimension (W * H * D)：
72mm × 72 mm × 58 mm
Panel cut-out (W * H)：

68 mm × 68 mm
Weight：
190g (0.42 lb.)
Protections and parameters：

Auxiliary shutdown protection : 1 Sec., Normal Close
Low battery warning : 5 Sec., 10.5 / 21 VDC
Over speed protection : 2 Sec.,55/66Hz
High water temp. protection : 2 Sec., Normal Open
Low oil pressure protection: 2 Sec., Normal Open / Normal Close
Over crank : 3 attempts
Cranking speed up limited : 0.5 Sec ., 20Hz
Safety on timer: 5 Sec (*)
(*) All alarms are ignored until safety on timer expired, except the emergency stop and over speed.
Ver.:V1703 5
GTR-17
6. Controller Wiring Example
Fig. 5 Controller wiring
Ver.:V1703 6

Generator Controller Manual

Uploaded by

Copyright:

Available Formats

Generator Controller Manual

Uploaded by

Document Information

Original Title

Copyright

Available Formats

Share this document

Share or Embed Document

Sharing Options

Did you find this document useful?

Is this content inappropriate?

Copyright:

Available Formats

Generator Controller Manual

Uploaded by

Copyright:

Available Formats

GTR-17

Tres Arroyos 329 - Haedo (1706)

: (54-11) 4926-0600 / 4483-3630

Fig. 17 Front Panel

3. Back Panel Function Description

Fig. 2 GTR-17 Controller Back Panel

Number Description Code

1 Input power (Battery +) ++

2 Ground (Battery -) GND

3 Output starter relay Motor

4 Output fuel valve relay Valve

5 Output alarm relay Alarm

6 Output stop relay Stop

7 Output Idle/Pre-heat relay Pre-Heat

8 Charge fire point Charge

9 Aux. switch shutdown Em.Stop

10 Input , High water temp. switch H.W.T.

11 Input, Low oil press. switch L.O.P.

12 Input , Auto start ATS

13 Input , Frequency detect terminal F.D1

14 Input , Frequency detect terminal F.D2

List 1 GTR-17 Terminal

A、Dip switch settings function

List 2 Stop Period

List 3 Cooling Time

Ambient Temperature Range：

Panel cut-out (W * H)：

Protections and parameters：

6. Controller Wiring Example

Fig. 5 Controller wiring

You might also like