CATEGORY - Green (III) Consent To Establish

Pollution Control Committee
Daman & Diu and Dadra Nagar Haveli

1 st Floor, Udyog Bhavan, Bhenslore, Nani Daman
_______________________________________________________________________________
CATEGORY - Green(III) CONSENT TO ESTABLISH
Consent No. PCC/DDD// 556563 Date :04/02/2020
In exercise of the powers delegated to the Pollution Control Committee, Daman, Diu and Dadra &
Nagar Haveli by the Central Pollution Control Board vide notification No.B-12015/7/92 published
in the gazette of India No.746 dated 26/11/1992 and administration order No.45/1(1)/92-F&E/4700
dated 8/2/1993, the consent is hereby granted under Section 25, Sub section (1) & (2) of Water
(Prevention & Control of Pollution) Amended Act, 1988 and under Section 21 of Air (Prevention &
Control of Pollution) Act, 1981 and the rules and orders made there under to manufacture below
mentioned products at the below mentioned address subjected to the following terms and
conditions.
Consent is granted to :
M/s Orbit Lubricants

Gala No. 53/3, Plot No. 26/A, Danudyog Industrial Estate, Village - Piparia, Silvassa - 396230
1. The Consent to Establish is granted for a period up to : 31/01/2021

2. The Consent is valid for the manufacture of following items:
Products Manufactured
Sr. No. Name of the Products Maximum Production Qty per Year
1 Industrial & Automotive 500 MT/Annum
Lubricating Oil, Viscosity
Improver (V. I), Break Fluid,
Coolant, Grease, Antistatic Oil,
Coning Oil, Warping Oil,
Twisting Oil, Yarn Oil, Knitting
Oil, Silicon Oil, Various Types
of Easter & Emulsifier,
Specialty Oil, Chemicals & Re-
Packing Various Types of
Greases & Oil.
3.Conditions under Water Act:
3.1The daily water consumption and wastewater generation is as under :-

Sr. No. Purpose Consumption(Kilo litter/day)
1 Domestic 0.0
Sr. No. Generation Waste Water Generation Quantity
(Kilo litter/day)
1 Domestic 0.0
3.2Trade Effluent. If any; the quality of the treated effluent as per PCC norms mentioned Below;
(1) pH Between 6.5-9.0

(2) Suspended Solids Not to exceed 100mg/L.
(3) BOD, 3 days, 27°C Not to exceed 100mg/L
(4) C.O.D. Not to exceed 250mg/L.
(5) Oil & Grease Not to exceed 10mg/L.
3.3Trade Effluent Disposal Oulet Conditions: Industry shall not discharge treated Effluent outside
factor premises. the treated Effluent shall be reused/recycled or used for plantation/gardening within
the factory premises.
3.4Sewage Treatment. - Domestic effluent shall be disposed off through septic tank/soak pit system
to conform to the following standards.
BOD (5 days at 200 C) less than 20 mg/l

Suspended solids less than 30 mg/l
Residual Chlorine minimum 0.5 mg/l
The unit shall comply with the following conditions:

1.The unit shall carry out manufacturing process by way of only blending at normal temperature.
2.The unit shall not carry out any kind of heating process.
3.The unit shall not carry out any type of washing activity.
4.The applicant shall collect & store the waste i.e waste/used oil, plastic waste, ink residue, empty
tin/containers etc generated from the process/plant and machinery inside the factory premises and
shall maintain a separate register to recording details such as generation, disposal, name of the
recycler/re-processor to whom sold etc.
5.The unit shall not generate any kind of fugitive emission during the process
6.The unit shall apply separately for any installation under air act.
7.The unit shall not generate/discharge any industrial waste water and any fugitive emission from
the manufacturing process or any ancillary operation in the plant.
8.The unit shall apply for consent to operate before starting the manufacturing process.
4. Conditions under Air Act:
4.1The following shall be used as fuel in emmission causing installation
Installed Utility Capacity Fuel. Quantity
4.2The flue gas emission through stack attached to emmission causing installation shall conform to
the following standards:
Sr. Stack Stack Capacity Stack height Fuel to be Permissible Limit

No. No. attached to in Meter used
4.3The concentration of the following parameters in the ambient air within the premises of the
industry shall not exceed the limits specified hereunder:
Parameter Permissible Limit

Particulate Matter(size less than 10µm) or PM10 µg/m3 100 (24 hours average)
Particulate Matter(size less than2.5µm) or PM2.5 µg/m3 60 (24 hours average)
Oxides of Nitrogen(NO2) µg/m3 80 (24 hours average)
Oxides of Sulphur (SO2) µg/m3 80 (24 hours average)
4.4The applicant shall provide ports in the chimney/stack and facilities such as ladder, platform etc.
as per requirements for monitoring the air emissions and the same shall be open for inspection and
use by the committees staff. The chimney /stacks attached to various sources of emission shall be
designated by numbers such s S-1, S-2 etc and these shall be painted/displayed to facilitate
identification.
4.5There shall be no emission other than the permitted installations and the quarterly stack
monitoring reports from recognized lab shall be submitted along with the renewal application.
4.6The applicant shall provide required stack height with the thermic fluid heater using the
following formula:
H=14 Q 0.3 Where H= total stack height in meters from ground level.
Q= Sulphur dioxide (SO2) emission rate in kg/hr. In no case the stack height shall be less than 11
mtr
4.7The applicant shall provide necessary control equipments with a minimum stack height of 11
mtrs to meet the SO2 norms.
4.8Each of the D.G.Sets shall be provided with a stack whose height, should be worked out
according to the formula;-
H = h + 0.2 capacity of KVA
Where h= height of the building in meters where the generator set is installed. OR9 meters form the
ground level, whichever is more, before commencing the operation.
4.9Adequate mufflers shall be provided to the D.G.Set/s, so that the ambient noise level shall not
exceed the limits prescribed below;
(a). Day time (6AM- 9PM)- 75 dB(A) Leq.

(b). Night time (9PM- 6 AN)- 70 dB(A) Leq.
5.GENERAL CONDITIONS: -
5.1Any change in personnel, equipment or working conditions as mentioned in the consents

form/order should immediately be intimated to the Pollution Control Committee.
5.2If at any time, it is observed that effluent fails to confirm to the limits prescribed, consent will be
withdrawn prohibiting the industry to manufacture either existing or new products.
5.3 The applicant shall submit separate application for obtaining Consent for Operation/ Renewal
under Water (Prevention and Control of Pollution) Act, 1974, and Air (Prevention and Control of
Pollution) Act, 1981 before 30 days of expiry of validity period of Consent.
5.4 This consent is further subject to green up the surrounding area inside and outside the
unit/factory.
5.5In case of change process/installation, which is likely to have discharge/an emission a separate
application shall be made.
5.6In case of failure to comply with any of the consent conditions, the consent order issue to you
stands automatically revoked without any notice on this behalf.
5.7If all the machineries listed in the project report are not installed operational consent shall not be
granted.
5.8The industry shall comply with Water (Prevention and Control of Pollution) Cess Act, 1977, and
submit monthly Cess returns as contemplated in the Act, in the prescribed form.
6.0The applicant shall comply with the notified standards under Environment (Protection) Act,
1986.
7.0The applicant shall comply with any and all the rules of Plastic Waste (Management and
Handling ) Rules, 2011 dated 4.2.2011.
8.0 The applicant shall not manufacture any products which attracts EIA notification dated
14.9.2006
9.0If the unit generates hazardous waste during the manufacturing process it shall be disposed off
scientifically to the CHWTSDF. The unit shall obtain CHWTSDF membership also.
10.0 Applicant shall also comply with the general conditions given in annexure I.
05/02/2020
Member Secretary
Pollution Control Committee
Daman, Diu and Dadra & Nagar Haveli
Daman

CATEGORY - Green (III) Consent To Establish

Uploaded by

Copyright:

Available Formats

CATEGORY - Green (III) Consent To Establish

Uploaded by

Document Information

Original Title

Copyright

Available Formats

Share this document

Share or Embed Document

Sharing Options

Did you find this document useful?

Is this content inappropriate?

Copyright:

Available Formats

CATEGORY - Green (III) Consent To Establish

Uploaded by

Copyright:

Available Formats

Pollution Control Committee

Daman & Diu and Dadra Nagar Haveli

CATEGORY - Green(III) CONSENT TO ESTABLISH

Consent No. PCC/DDD// 556563 Date :04/02/2020

M/s Orbit Lubricants

1. The Consent to Establish is granted for a period up to : 31/01/2021

3.Conditions under Water Act:

3.1The daily water consumption and wastewater generation is as under :-

(1) pH Between 6.5-9.0

BOD (5 days at 200 C) less than 20 mg/l

The unit shall comply with the following conditions:

4. Conditions under Air Act:

4.1The following shall be used as fuel in emmission causing installation

Installed Utility Capacity Fuel. Quantity

Sr. Stack Stack Capacity Stack height Fuel to be Permissible Limit

Parameter Permissible Limit

(a). Day time (6AM- 9PM)- 75 dB(A) Leq.

5.1Any change in personnel, equipment or working conditions as mentioned in the consents

You might also like