Defender / Discovery 1 Engine Service Parts Page 1

'94-'99 Discovery 1 North American Specification, U.S. models VIN number model years: PA-'93 RA-'94
'93 Defender 110, '93-'97 Defender 90 NAS U.S. models only SA-'95 TA-'96 VA-'97 WA-'98 XA-'99
Filters
Oil for Genuine use ERR3340GEN ERR3340G K&N hi-performance oil filter HP2004 Tech tip:
Air Discovery 1 original type ESR1445 It's critical to
K&N high performance 33-2737 only use
Defender original type RTC4683 filters with
K&N high performance E-2350 anti-drainback
valves: serious
K&N service kit 99-5000
engine damage
Fuel ESR4065 may result.
K&N E-2350 For more info on Not all filters out
Ignition K&N Performance filters, go to there do.
Spark Plugs ERR3799 britishpacific.com / offroad /K&N Ours are right.
Plug Wire Set 3.9 .
RTC6551P use with coil wire LRN192428; for genuine use RTC6551G
4.0 GWS101
Distributor Cap STC8368G Genuine
Distributor Rotor STC1857G Genuine
Ignition Module 2 pin NLA use STC1184, plus STC1212 link lead
3 pin STC1184
Vacuum Advance 2 pin type RTC3201
3 pin type STC1186
Pick up and base plate RTC5090 up to eng. 35D09449B / 36D28463B
STC2898 from eng. 35D09450B / 36D28464B
Ignition coil Distributor type, Genuine RTC5628GEN aftermarket RTC5628P
Distributorless ignition coil pack ERR6269 all 8 cylinders only

"V" Belts
Fan belt 611612
Steering pump belt ERC675
A/C compressor belt 611612
Alternator belt ERR2678
"Serpentine" Belts Defender ERR5579
Discovery 1 3.9 ERR4623
ERR3440 STC483 ETC1275
Discovery 1 4.0 ERR5579
Tensioner assembly ERR3440

Ancillary Assemblies
Water Pump ‘V’ belt system STC483
Serpentine system Genuine STC4378 for aftermarket use STC4378P
Viscous Fan Drive
Defender ‘V’ belt system ERC5708
Discovery 1 ‘V’ belt system ETC1260
Serpentine belt system ERR3443 STC4378
Cooling Fan
7 blade ‘V’ belt system, Defender type ETC7553
11 blade ‘V’ belt, Discovery 1 type ETC1275 for genuine use ETC1275G
Serpentine belt system ERR3439
Steering Pump
‘V’ belt system NTC9198
Serpentine belt system QVB101110
Alternator
Defender 3.9 85 AMP use YLE10100
Defender 3.9 100 AMP YLE10100
Defender 4.0 100 AMP AMR4247 52 mm pulley
Discovery 1 67 mm pulley AMR3107 up to vin SA163099 / SA501919 100 AMP
Discovery 1 52 mm pulley AMR4247 from vin TA163100 / TA501920 100 AMP
Starter
Defender up to Jan. ’93 RTC6061 Lucas/Marelli
Solenoid for above STC943
Defender, Discovery 1 NAD101490 Bosch
Solenoid for above STC1242
Defender / Discovery 1 Catalog Index Pg. 7: Suspension Page 13: Books, Manuals, Videos
Page 2: Engine gaskets, heads, senders Page 8: Steering, Fuel, Exhaust Page 14: Disco Interior Accessories
Page 3: Engine: block, cam , clutch Page 9: Brakes Page 15: Defender Gear, Offroad
Page 4: Transmission, Transfer Case Page 10: Cooling
Page 5: Driveshafts, Differentials, Wheels Page 11: Body Electrical
Page 6: Axles/Hubs Page 12: Body Electrical, Body Approved U.S. Distributor
British Pacific is an independent specialist distributor of Land Rover parts and accessories: manufacturers part numbers are used for
reference purposes only. Not all parts shown are Genuine Land Rover. Order Line: 800 554-4133 Hours: M-F 9-5 Pacific
 Defender / Discovery 1 Engine: Gaskets, Heads, Senders Page 2
Gaskets/Seals
'94 Discovery, '93-95 Defender 3.9 V8 with V belt system and shim steel head gaskets
Head set STC1641
Block set STC1639
Oil pan gasket 602087
Drain plug crush washer 213961L
Valve cover gasket 602512 ERR7306
rubber type LVC100260
Head gasket, shim steel ETC7819
composite ERR7217
Valley cover, shim steel ERC3990
rubberized type ERR7306
Valley end seals 602099 ERR7217
Timing cover gasket ERR4936 Head Sett
Front main seal ERR6490 dual lip
Rear seal retainer packing 611089
LVC100260
Rear main seal ERR2640
Water pump gasket ERR2428
Exhaust manifold gasket, head side ERR6733 2 per manifold, newer replacement
Thermostat housing gasket ERR2429

'95-'99 Discovery 1, '97 Defender 3.9 and 4.0 V8 with serpentine belt system and composite head gaskets
Head set STC4082 requires new head bolts when head gaskets are replaced:
Block set STC2823 ERR2943 x 7, ERR2944 x 3, per head: 14 & 6 total
Oil pan gasket 602087
Drain plug crush washer 213961L
Valve cover gasket LVC100260G for Genuine use LVC100260GEN
Head gasket ERR7217
Valley cover gasket ERR7306
Valley end seals ERR7283 clamps for seal: ERR7282
Timing cover gasket ERR7280 ERR7283
Water pump gasket ERR4077
Exhaust manifold gasket, head side ERR6733 2 per manifold
Thermostat housing gasket ERR2429
Front main seal ERR6490
Packing for rear main seal 611089 Valve cover molded hoses:
Rear main seal ERR2640 LLH500090 RH cover to ram housing
ERR5039 LH cover to plenum
ERR6733
Cylinder Head
Intake valve LGH000030
Exhaust valve LGH000040
Valve spring ERR4628
Valve guide LGJ100900 intake and exhaust the same
Intake stem seal ERR1782 no exhaust seals used
Rocker shaft 611659L
Rocker arms: right handed pad 602153
left handed pad 602154
Push rods 603378

Senders, Engine Mounted 602153 602154

Oil pressure switch STC4104K mounts in timing cover
crush washer 243967 if fitted with O ring use STC3372: do not use both
Water temperature transmitter PRC7918 D110 only
PRC4430 D90 only, up to '96
AMR1425 Discovery, Defender '97: uses crush washer 243967
Fan temperature switch PRC3505
crush washer C457593
Engine coolant temperature sender ETC8496
crush washer 243967 ETC8496 PRC3505 STC4104K

Secure On-Line Ordering at Britishpacific.com: phone orders toll free at 800 554-4133

Secure On-Line Ordering at Britishpacific.com: phone orders toll free at 800 554-4133
 Defender / Discovery 1 Engine: Block, Cam, Clutch Page 3
Engine block
Short block 3.9 ERR4165 call for availability
4.0 LBB111520 new
Pistons 3.9 standard STC909S comes with rings and wrist pin
4.0 standard ERR5553 comes with rings and wrist pin
Rings 3.9 standard RTC6066S does one piston
3.9 .020 oversize RTC6066/20 “
4.0 standard STC1427 “
Rod bearings 3.9 RTC2117 .010 over: RTC2117/10 .020 over: RTC2117/20
4.0 STC1426
Main bearings 3.9 RTC1718 .010 over: RTC1718/10 .020 over: RTC1718/20
4.0 STC4299
Pilot bushing 549911
Timing chain crank gear ERR2958
Timing cover
Woodruff key for above ERR2846
assembly,
Oil pump 3.9 V belt, up to '94 ERC1351 shaft and gear with oil pump
614037 idler gear
ETC4276 pump assembly
ERR1990 gasket
Timing cover assembly 3.9 V-belt ETC7385 integral oil pump (non serviceable)
3.9 serpentine ERR6814 integral oil pump (non serviceable)
4.0 ERR6815 integral oil pump (non serviceable)
Camshaft 3.9 ERR5924 use thrust plate ERR5926 on engines so equipped
4.0 ERR3720 use thrust ERR2609
Cam Gear 3.9 610289
4.0 ERR5086
Crank gear ERR2958
Crank sensor call with VIN number
Timing chain ERC7929
Tappet (lifter) ERC4949
Cylinder heads LDF001020 without secondary air
LDF001040 with secondary air
Engine mounts STC434 up to '95
'95 on KKB103120
nuts for above FN110047
Core plugs & screws
Cam bore back of block 602146 1 required
Screw plugs back of block 602212 2 required
Freeze plugs 602152 8 required (3 on each side, 2 in back)
Oil drain plug 29mm 603659 crush washer ETC7398

Clutch
Defender disc FTC4662
pressure plate 576476
Discovery plate & disc set FTC4828
Throw out (release) bearing FTC5200
Staple clip 576203
Retainer clip 571163
FTC4828
Clutch Hydraulics
Slave cylinder Defender FTC5071 LT77S transmission
Discovery FTC5072 R380 transmission
Rebuild kit Defender BHM7063L LT77S transmission
Discovery STC2818 R380 transmission
Flex hose, slave line NRC2211
550732
Master Cylinder Defender 550732 uses reservoir cap STC976
Rebuild kit 8G8837L
Discovery ANR2186 uses reservoir cap STC1646
Rebuild kit STC1126
www.britishpacific.com 800 554-4133 britpac@aol.com fax: 661 257-9765
British Pacific: 26007 Huntington Lane, unit 2, Valencia, CA. 91355. 30 miles north of Los Angeles.
 Defender / Discovery 1 Transmission, Transfer Case Page 4

ZF Automatic Transmission
Filter set RTC4653KIT includes filter, pan gasket, o-rings
Pan gasket RTC4268 included in the transmission overhaul gasket set
Filter screen only RTC4653
O-ring RTC5818 to filter screen
O-ring RTC4276 screen to pick up tube
Drain plug RTC4647
Crush washer STC1060
Front input seal RTC5102 oil pump shaft: included in RTC5100
ZF Transmission oil cooler lines
Discovery UBP101030 trans to cooler
ESR3695 radiator to cooler RTC4653KIT
UBP101020 cooler to trans
O-rings, cooler lines ESR1594L 6 required
Oil temperature switch 8510043 uses crush washer 232039
Defender call with VIN number: numerous variations

ESR3695 UPB101020
Illumination unit
BTR9926LNF
all Disco 1's &
'97 Defender

LT77S Manual Transmission FITTED UP TO ABOUT MAR’94

Overhaul gasket set RTC6797 includes gaskets and seals
Oil seal, front input housing FTC5303
Fill (level) plug 3292
Drain plug FRC6145 magnetic
Crush washer FRC7064
Filter plug / extension case 90571104
Filter screen FRC6244
Crush washer FRC4810
Oil cooler 110 ESR488
Oil cooler lines please call with VIN number

R-380 Manual Transmission FITTED FROM ABOUT MAR. ‘94

Oil seal, front input housing FTC5303
Drain plug FTC4056
Drain plug, magnetic FRC6145
Crush washer FTC4112
Oil filter FRC7855
O-rings, cooler lines ESR1594L 4 used
Transmission mounts, Defender STC434 up to SA966426 (about mid '95), 2 used
later type KKB103120 from SA966427 (mid '95 on)
nuts, nyloc NY110047L 2 per mount

Transfer Case LT230 for E-brake system see brake section

Gasket & Seal kit RTC3890
Input seal ICV100000
Output seals FTC4939 2 required, front and rear are the same
T-case mounts ANR2805 2 fitted
nuts, nyloc FX112041L 2 per mount

Don't see what you're looking for? Call or e-mail us: 800 554-4133 or britpac@aol.com
 Defender / Discovery 1 Driveshafts, Differentials, Wheels Page 5

Driveshafts
Front, complete shaft with u-joints FRC8641
Rear, for Rotoflex rubber coupling TVB000150
Conversion from rubber Rotoflex to standard u-joint, rear drive shaft, Discovery: for heavy duty use
Driveshaft FRC8387, Flange Kit STC4858, Spacer 539745, bolts 509045P (x 4), nyloc nuts NZ606041L (x 8)
U-Joints Defender 110 all RTC3458
Defender 90, front TVC100010 STC4858
Defender 90, rear RTC3458
Discovery TVC100010 2 front, 1 rear (without Rotoflex add 1 more)
Rotoflex Coupling Discovery only TVF100010 used up to VA541627/VA710668, mid '97
with attachment bolts TVF100010G coupling with new hardware
Front shaft boot Defender 110 276484 protects sliding spline
Defender 90, Disco 276483
Flange bolts 509045P 4 per flange (all except Rotoflex)
Flange bolt nyloc nuts NZ606041L TVF100010

Differential
Ring & Pinion set 3.54 ratio FTC3620 original ratio; includes FTC5413 & FS112301P
4.70 ratio RTC2990 optional ratio for improved power delivery offroad
4.11 ratio front GBR411F optional ratio, critical when running taller tires
rear GBR411R
NOTE: ON DISCOVERY MODELS EQUIPPED WITH ROTOFLEX DRIVESHAFT YOU MUST REPLACE THE REAR PINION FLANGE
AND REAR DRIVESHAFT WHEN FITTING 4:11 or 4:70 GEARS. YOU MUST ALSO REPLACE GEARSETS IN BOTH AXLES.

ARB Air Lockers Air compressor kit RDCKA Air Locker conversion requires RDCKA plus RD56
Differential kit RD56 one per axle, fits either axle except D110 rear: use 1 or 2.
Carrier Bearings RTC3095
D110 rear RD32 Salisbury axle RDCKA
Optional tire inflation kit PUK Compressor
NOTE: REQUIRES RING GEAR SPACER AND LONGER RING GEAR BOLTS (10 REQ.) WHEN USING 4:70 GEARS
Ring gear spacer RD03A longer bolts req.: 576521
Pinion gear nyloc nut NY116041L
Pinion shims 1.548 MM FTC3853
sizes up to 1.198MM FTC3867 call with size requirements
Front (outer) pinion bearings 539707
BP is America's oldest ARB dealer!
Rear (inner) pinion bearings 539706
Pinion seal FRC8220 up through '97 RD56
FTC5258 '98 on Locking
Differential carrier side bearings RTC3095 Gear
Spider (side) gears STC1846 kit contains 4 gears Carrier
Spindle (cross shaft) 599945
Gasket, Diff housing 7316
Drain plug crush washer 515599

Wheels and Lug Nuts

Steel Wheels Defender 90 ANR1534PM
Defender 110 ANR4636PM 7.50 X 16" tire, also used on Discovery
Discovery NTC5193PM factory steel rim, tough and strong
'Wolf' Wheel, all models ANR4583PM with bead lock, great for offroad work
Steel rims are commonly used on Defender and Discovery for fitting off road, mud, or snow tires: ours are OEM. GLN001
Alloy wheel center cap ANR2391MNH 3" diameter
Lug nut / universal ANR2763MMM capped and flared for alloy and steel wheels
Lug nut / steel wheels only RRD500010 ANR2391MNH
Locking lug nuts, alloy wheels GLN001

ANR1534PM ANR4636PM ANR4583PM NTC5193PM

BP'S hours are 8-4, M-F, west coast time britpac@aol.com 800 554-4133 britishpacific.com
 Defender / Discovery 1 Axles / Hubs Page 6

Axle Seals, Gaskets Rover type axles: for D110 Salisbury rear diff, see below.
Outer hub seal D90, Disco 1 FTC4785
D110 front FRC8222
Swivel ball seal FTC3401
seal retainer D90 571775 D110, FRC4142
Axle flange gasket D90,110 FTC3646 diff to swivel ball, up to '97
Disco 1, D90 '97 FTC3648
Swivel pin seal kit STC3321 does one side of axle per kit
Hub cap FTC5414
Hub cap gasket 571752 all 4 wheels except D110
Inner shaft seal D110 571718
D90 to mid '94 FTC840 up to RA930445
D90, Disco 1 FTC3276

Axles / Hubs, Front

Front halfshaft assembly
Hubs and Axle Components:
D90, Discovery 1 left TDB000190 1. Brake Rotor
right TDB000180 2. ABS Sensor (when fitted)
D110 call with requirements 3. Inner hub seal
4. Axle housing breather
Axle shaft bearing FTC861 5. Lock tabs (2 per side)
Seal, stub axle FTC3145 6. Hub nuts (2 per side)
Thrust bushing, non ABS FTC56 7. Gasket, hub cap
CV joint D90 up to ’97: use halfshaft assembly 8. Wheel stud
9. Wheel bearings
D90 ‘97, Discovery 1: H/D TDJ000010G 10. Inner hub seal (if fitted)
standard duty TDJ000010P 11. Stub axle
D110 RTC6862 12. Axle shaft
13. Swivel pin
Swivel pin bearing, lower 606666 14. Swivel ball housing
Swivel pin, lower FRC2894 15. CV joint
Upper swivel pin, D90 to ‘97: FTC2882 16. Swivel bearing
shim call for sizes
bearing 606666
Discovery 1, D90 ’97 only STC226 pin kit; includes pin, thrust washer
bearing: FTC2065 Swivel Grease Packet STC3435P
D110 Upper pin FRC3511 one tube fills one swivel: easy to use, works great
Shim call for sizes
Railko bush FRC2906
Housing & bush FRC2916
Upper swivel pin bearing:
D90 to ‘97 606666
D90 ’97, Disco 1 FTC2065
Upper swivel pin shims (.003) FRC2883 range to FRC2886 (.030): call for intermediate sizes
Swivel drain plug D90, Disco 1 236070 uses seal washer 230511
D110 3290
Swivel fill plug D90, Disco 1 3292 STC3321P
D110 3291
Swivel level plug FTC3670
Swivel seal kit (does one side) STC3321P
Wheel bearings RTC3429 uses locker FTC3179

Axle, Rear Hub seals, wheel bearings, hubcaps, gaskets, and seals; same as front (exc. D110)
Center ball joint, all models ANR1799 Rover Type Axle
Boge self levelling unit D110 NRC7050
Ball joint 575882 uses 2
Axle shaft D90, Disco 1 left FTC3271 right FTC3270
D110 left FRC2454 right FRC2455
Rear hub bearings D110 RTC3429
Inner hub seal D110 FTC4785
Outer seal D110 FRC8222
Drive flange gasket D110 FRC3988
Hub cap D110 FRC4377 Salisbury Type Axle

D110 Salisbury Rear Differential

BP hours: Please
9:00 AM- 5:00 call with
PM (west requirements:
coast most items
time: -3 hours fromare
theineast
stock.
coast, +3 to Hawaii)
Tech help line: 661 257 9765, for as long as you require. Orders: 800 554-4133
 Defender / Discovery 1 Suspension Page 7
Suspension
Springs, High Performance Replacement Old Man Emu Defender 90 and Disco 1 the same unless noted
Front Medium OME761 1 -3/16" lift over stock, for up to 110 lbs. extra weight
Front Heavy OME751 1 -3/8" lift over original height, for up to 240 lbs. extra weight
Rear Medium OME764 1 -9/16" lift over original height
Rear Heavy OME762 2" lift over original height, 440 lb.constant load
Rear D110 ‘soft’ OME752 smooth ride: good for off road if lightly loaded
Rear D110 heavy OME755
Rear Disco 1, extreme duty OME763 Minimum constant load 440 lbs.; 1.26" lift over original (Stiff)

Heavy duty springs are recommended only when heavy loads are carried continuously. Medium work fine in most cases, and will carry more
than stock. Heavy loads equait to (front) ARB bull bar plus winch : (rear) combinations of rear area passengers, roof rack gear including
tents, and trailer tongue weight. All 4 springs are different, exactly like factory springs. Please refer to the 'Emu' pages of the 'Off Road'
section on our website: britishpacific.com, or call 800 554 4133. We'll make sure you get the right set up!

Springs, Stock Replacement Coil springs need replacement about every 7 years, or if the truck noticably leans to one side.
“Left” refers to driver's side: replacement of old springs will lift the vehicle significantly, back to original height.
Defender 90 Left front NRC9446
Right front NRC9447
Left rear NRC9448
Right rear NRC9449
Defender 110 Front left NRC804
Front right NRC8045
Rear left NRC6388
Rear right NRC7000
Discovery Left front NRC4306 blue/white stripe
Right front 572315 blue stripe
Rear ANR3477 both sides the same

Spring Seats
Front: Defender, Disco NRC9700 all Disco & D110, D90 to mid-’94 (RA939980)
D90 from RA939981 ANR3578 mid-’94 on Air Boosters
Rear D90, Discovery lower NRC9700 Add to your rear
Disco, upper ANR2938 coil springs for
increased load
capacity. They
Shocks, Factory Replacement preserves the original ride, fine for light off road use inflate like a tire
Front Defender 90 STC3766 for periodic
Defender 110 STC3769 heavy work with
all coil springs.
Discovery STC3703G
Rear Defender 90 STC3767 Stock springs:
Defender 110 STC2854 D90: 61741
Discovery STC3704G Disco 1: 61758
Emu springs:
61737
Shocks, Heavy Duty
(Old Man Emu gas type: strongly recommended when adding OME springs, but also work well with stock)
Front N45F Urethane bushings included
Rear N46 Urethane bushings included
Shock tower, front NRC6372
Mounting ring, front 572087 uses nuts NH605041L

Bushings
H.D. Emu Urethane Bushings
Panhard rod original rubber ANR3410 2 required per rod
urethane OMESB65 1 kit does 2 rods
Radius arm to axle, rubber, D90 NTC6781 2 per arm
Disco NTC6860 2 per arm
D110 NTC7307 2 per arm
STC618
urethane OMESB72 1 kit does 2 arms
Radius arm to frame, rubber NRC4514 2 required per arm
urethane OMESB74 1 kit does 2 arms
Trailing arm bush NTC9027 set of 2: STC618
Shocks: front, original rubber 552818 4 per shock
urethane OMEB42 1 kit does 2 shocks
Rear, original rubber, upper NRC5593 2 required
Defender lower 552818 Up to VA: 2 per shock
D90 lower, ‘97only RNF100090L automatic models
Discovery lower ANR1721
urethane upper OMEB36 1 kit does 2 shock uppers Complete Polybush Sets
lower OMEB42 1 kit does 2 shock lowers rides like rubber,
Sway bar mount bushings tough like urethane!
Front, rubber NTC6828 2 per bar
Rear D90 EGP1889 2 per bar Full Vehicle Set GAL105
Rear D110 NRC5674 2 per bar HD Defender 90 GAL101
Rear Discovery, rubber NTC7394 2 per bar
Use 'Price Lookup' for current prices: works on any page without having to change screens! Open it at the homepage.
 Defender / Discovery 1 Steering, Fuel, Exhaust Page 8

Steering
Steering Box, new QAF500040 brand new, Genuine
Remanufactured 109480P upgraded type: 250.00 core charge, refunded upon receipt of old box
Seal kit STC2847 all most leaky boxes need
Drop Arm D90, D110 STC1045
Discovery NTC9235
Ball Joint kit RBG000010 Front Suspension and Steering, looking from the back to the front:
Track Rod ends (Tie Rod ends) right handed thr. RTC5869G
left handed threads RTC5870G
Steering Damper D90, D110 RTC4472
heavy duty, Old Man Emu OMESD32
Discovery STC786G
heavy duty, Old Man Emu OMESD11
Steering Protector D90, D110 GAL048
Discovery GAD045

Steering Column: D90, D110

Upper U-Joint NRC7387
Lower U-Joint NRC7704 Track Rod Ends
Steering Shaft assembly RTC4738 Steering Damper
Discovery Drop Arm & Ball Joint
Upper Shaft assembly ANR3171
Lower Shaft & U-Joint STC2800 Steering box seal kit STC2847
Power Steering Hoses Discovery
Reservoir to pump NTC9989
Box to reservoir (low pressure) QEH102370
Pump to box (high pressure) ANR6656
ANR6656
Fuel System
Accelerator cable GAL048 Defender steering protector
Defender: 90/110 manual trans. NTC9163 please refer to the Offroad section of our
D90 automatic trans. NRC5494 website for more off road gear
Discovery ANR16311 up to TA700853 or TA531679 (up to mid '96)
ANR5327 from TA700854 or TA531680 (mid '96 on)
Fuel Pump fitting kit required for all pumps: olive NRC9771 (x2), plus nut NRC9770 (X2)
D110 PRC8318 uses separate sender
D90 ESR3928 use sealing ring NTC5859
Discovery Pump assembly ESR3926 to VA714241 or VA546029 (up to mid '97) ESR3926
sealing ring NTC5859 for above
Pump assembly WFX101020 from VA714242 or VA546030 (mid '97 on)
sealing ring WGQ500020 for above
Fuel level sender D110 only AMR2365
Cap, fuel tank WLD100820
locking LRNAGCAPL
Injectors ERR722 one per cylinder
Ring seal, upper EAC2414L 1 per injector INJECTOR SEALS INCLUDED IN HEAD GASKET SET
Ring seal, lower EAC2415L 1 per injector INJECTOR SEALS INCLUDED IN HEAD GASKET SET
O-rings RTC5679 2 per injector
Air flow meter Defender ERR5198 '93-'95
ERR5595 '96 on
Discovery ERR5595
Stepper motor Discovery & D90 4.0 ERR4352
Throttle position indicator potentiometer ERR2263 ERR722
Fuel filter, in line ESR4065
Exhaust System
O2 sensor (‘Lambda’ sensor) ERR6729 models with 2 fitted, '94-'95
Heated type (AELCS) ERR1834 models with 4 fitted, '96-'97 with black plug
AMR6244 models with 4 fitted, ’97 on with gray plug
Gasket, manifold to headpipe ETC4524 1 per side
manifold to head, individual port type ERC3606 8 used, 4 per side INCLUDED IN BLOCK KIT
paired gasket type ERR6733 4 used, 2 per side ERR6729
Locking tabs, manifold bolts ERC7321
Donut, head pipe to tail pile CRC4579L
Rubber hanger grommet ('pig snouts') NTC5582 3 fitted, Disco & D110: 2 fitted, D90 manual
D90 automatic ESR3172 2 FITTED STC3717
Intermediate pipe with muffler, Discovery STC3716
Tailpipe with silencer, Discovery STC3717 mild steel as original
Olive seal, required with above CRC4579L
Headpipes with catalysts & other tailpipes available: please provide your VIN number, and specify if it's a California model.

Looking for prices? Go to britishpacific.com: 'Price Lookup' and 'Secure On-line Ordering' are both available at the
home page. 'Price Lookup' can be used on any website page after it's been opened, without changing screens.
 Defender / Discovery 1 Brakes Page 9
BP offers a choice of OEM or premium aftermarket brake pads: OEM are original fitment, usually with pins and clips.
Brake pads or shoes are sold as an axle set; they do 2 wheels. Seal kits do one caliper.

Pads & D90,110 front OEM: SFP000260G - Ferodo: SFP000260F

Shoes Discovery 1 front OEM: STC9191 - Ferodo: STC9191F - Mintex: STC9191P
D90, Disco 1 rear OEM: SFP000270G - Ferodo: SFP000270F
Rear shoes, D110 only STC2797 Mintex
Pin & clip pad retention kit STC8575
E-brake shoes side adjuster STC965
bottom adjuster ICW500010
E-brake drum FRC3502

Rotors D90 front FTC902 vented STC1749

D110, Discovery 1 front FRC7329 non vented
D90, Discovery 1 rear FTC1381
D110 rear drum 576973 retention screws SA108161, 2 req.
Hub Seals FTC4785 strongly recommended when replacing rotors
Hub gaskets 571752

Calipers D110 front right RTC5572 pads not included

left RTC5573
D90 front right STC1266
left STC1267 STC1278
rear right STC1264 Pistons and
left STC1265 seals, does
Discovery 1 front right STC1962 one caliper
front left STC1963
rear right STC1264
rear left STC1265 AEU1547 seal kit: does
one front caliper, both rear.
Caliper rebuild kits: pistons and seals for one caliper
D110 front STC201
D90 front STC1280 Tech Tip: Brake Hydraulic System Care
D90 rear STC1279 Calipers require periodic maintenance for best
Discovery 1 front STC1278 brake operation. Replacing the brake fluid is an
Discovery 1 rear STC1279 LR specified maintenence procedure, to be done
Seal Kit D90, D110 front AEU2539 seals only roughly every 48,000 miles: this removes water
D90 rear AEU1547P AEU1547G and contaminates, preserving the seals and the
Discovery 1 AEU1547P AEU1547G piston surface. Should a piston begin to leak or
stick, usually a new piston and seal kit will put it
ABS sensor, Discovery front STC1749 right: no need for a whole caliper assembly. Any
rear STC1750 major brand of DOT 4 fluid will work fine. Our
Mityvac or our Power Bleeder are good tools for
110 Rear Wheel Cylinders right RTC3626 one person alone to do the job with.
left RTC3627
Bleed screw 608400
Seal kit AEU2498

Master Cylinder Defender SJC100460

Discovery 1 STC1284
Rebuild kit Defender STC491
Discovery 1 STC2903
Cap, reservoir, Defender NTC4414 Mityvac Pump
Universal Power Bleeder
Cap, reservoir, Discovery 1 RTC5831 pulls fluid through or
pushes fluid through the
Booster/Servo, Discovery 1 STC1286 empties reserviors
system: 101
Defender 90/110 STC4322 386-215
Vacuum valve STC780

Brake Flex Hose Defender, front NRC7874 Weight is

Defender 90, rear NRC9455 the enemy! SJC100460
Defender 110, rear NRC9456
All vehicles
Discovery 1, front ANR1765
have a GVW
Discovery 1, rear NTC3458 gross weight
rating. That's based on things like
the size of the master cylinder.
Genuine Castrol DOT 4 brake fluid: Do you know your safe load limits?
12 oz. GTLMA 32 oz. GTLMA/L
 Defender / Discovery 1 Cooling Page 10

Radiator
Discovery, manual transmission ESR3688
automatic transmission ESR3687 req. 4 x ESR1262 fittings
Defender 90 ESR3685 to SA977128
ESR204 from SA977129
D110 ESR204
Mount bushings 572312 4 required ESR3687

Radiator Hoses
Top hose, Discovery PCH000050 PCH000060
Defender NTC5686
Bottom hose, Discovery PCH000060
with advance evap loss PCH000070 see photo
Defender NTC3543 up to VA999171
ESR4223 from VA999172 on
Expansion tank, Discovery PCF101590
Expansion cap, Discovery NTC7161 PCH000070
Defender, all PCD100150

Thermostat
Defender, Disco ETC4765 housing gasket ERR2429

Cooling fans, Water pump, Belts, Viscous coupling see page 1

Heater Hoses, Discovery up to RA104738:

Heater to valve BTR8726
Valve to heater BTR8727 PCF101590
Engine to valve BTR4016
Valve to engine BTR8725
from RA104739:
Heater to valve PCH000100 2 required to SA163099/SA501919 (mid '95)
rear PCH000110 2 required to SA163100/SA501920
Heater control valve, Disco BTR4022 up to RA104738 ('94)
Heater core STC3135

Heater Hoses, Defender Water Wetter

D110 feed ESR1950 straight Add to cooling
ESR1951 curved system to improve
return ESR1952 heat transfer
and increase
D90 feed AWR6631
corrosion
return AWR6632 protection.
Concentrated,
Oil Cooler Pipes one bottle is
Discovery plenty.
feed, engine to cooler PBP101150 upper 80204
return, cooler to engine PBP101160 lower
Defender 110
feed, to PA922098 ESR583
from PA922099 ESR1915
return, to PA922098 ESR398
from PA922099 ESR1914
Defender 90 feed, manual trans. ESR1915
auto trans ESR3693
PBP101150 PBP101160
return, manual trans. ESR1914
auto trans ESR3692
For transmission cooling lines please see page 4

BP hours: 9-5, M-F, west coast time britpac@aol.com 800 554 4133 britishpacific.com
Ordering? Use britishpaific.com 'Price Lookup' for pricing, 'Secure On Line Ordering' to submit your
order. Both are on the home page. Questions? Use 'Ask Rover'. No LR site is easier to use than BP's!
 Defender / Discovery 1 Body Electrical: Lighting Page 11
Headlights Off road lighting can be found in our 'Off Road' section or our Acceccory Catalog
Defender stock replacement PRC5394 Sealed beam type
H4 Halogen 7" 920H IPF: no bulb, holder, or wiring: sold separately
H4 Halogen 7" GDL006 Wipac: sold as a pair, with street legal 60/55 watt bulbs
55/60 watt bulb HHC-126055 IPF street legal wattage
80/110 watt bulb HHC-1211080 requires use of heavy duty wiring harness below
Wiring harness, high watt M002 includes relays, required with high wattage lights

Discovery Bulb only 589783 stock replacement STC1232

Lens assembly left STC1238 Disco II style can be substituted,
right STC1237 replace in pairs. See pg. 6, Disco II
Gasket left STC1714
right STC1713
Attachment kit STC1232 one per headlight, adjusters
STC1238 Fog lights bulb only STC3085 H3 UV cut (req. low emission bulb)
Lamp assemblys left AMR5617 superseded to later style by LR
right AMR5618 superseded to later style by LR
Front Lights
Defender front running light lens STC868 2 11/16" amber, fits both, up to RA940004 (late ’94)
bulb for above 570822 #57 type
front running light AMR6525 mid-’95 on, from RA940005: bulb 570822, #57
turn signal lens LRN2040 in bumper
‘big’ turn signal lens AMR6527 superseded to later style XBD100770
AMR6527 superseded to later style
bulb for above 264591 21W, #1156 type
Discovery turn signal lens left XBD100770 up to ’98; chrome bezel type replaced by black bezel
right XBD100760 up to ’98; chrome bezel type replaced by black bezel
bulb for above 264591 21W, #1156 type
Front Facing Marker Lights
Defender, early D90, all D110 AMR2098 up to SA955972 (mid ’95)
later D90 left AMR2575 from SA955973 on (mid '95)
right AMR1292 “ “
bulb for above AFU4481
Side Facing Marker Lights AMR2098
Defender front D90, 110, early AMR2036 up to D90 SA955971 (mid '95) 'Truck-Lite'
later D90 front left AMR2575 from D90 SA955972 (mid '95 on)
IPF 9000front right AMR1292
rear D90, 110, early AMR2037 up to D90 SA955971 (mid '95) 'Truck-Lite'
later D90 rear left AMR2576
rear right AMR1293 AMR6526
Discovery front left AMR2575
Wiper Blades
front right AMR1292
rear left AMR2576
AMR2576
rear right AMR1293
Side Repeater Lamp- Discovery PRC9916 uses bulb AFU4481

Rear Lights
Defender tail lights, square lenses Red STC891 bulb 1157
XFC100550
Amber STC893 bulb 1156
Clear (back-up) STC894 bulb 1156
round lenses late style, lens only: plinth (base) AMR3850, screws DA606059L
Red AMR6526 bulb 1157
Amber AMR6527 bulb 1156
Clear (back-up) AMR6528
license light assembly XFC100550 spacer 345597 bulb 570822 (uses 2 bulbs) #57 type
reflector AMR2076
Discovery tail lights left AMR3954 up to SA162389/SA501474, mid '95
left AMR5150 from SA162390/SA501705, mid '95 on bulb #1156 type
right AMR3955 up to SA162389/SA501704, mid '95
right AMR5151 from SA162390/SA501705 bulb #1157 type
seal left MXC1047
right MXC1048 AMR6510
bumper lights left AMR6509
right AMR6510 bulb #1156 type
third stop light XFG100330 to VA71424/VA546029 mid '97
XFG100340 from VA714242/VA546030 mid '97 on
license light PRC5838 bulb holder assembly bulb RTC3633
gasket PRC7246
AMR5150
reflector, rear door MWC1722
 Body Electrical: Switches, Antenna Page 12
Defender / Discovery 1
Body : Mirrors, Wipers, Bumpers, Miscellaneous
Switches
Defender Ignition '93-'95 AMR2077 clamp QRG100100 shear bolts 51K4001L (2 req.)
'97 D90 auto trans QRF100860 use clamp and bolts above
Lights (head) '93-'95 PRC3430
'97 D90 AMR6104
Turn signal, horn D110 STC439
'93-'95 D90 PRC3875
'97 D90 XPB101290P
Wipers '93-'96 PRC7370 PRC3875 PRC3430 YRC100350
'97 D90 AMR6106
Disco 1 Lights, Turn signal STC4017
Ignition switch & lock STC1436 automatic transmission
STC1435 manual transmission
lock shear bolts STC2867
key blank CWE10032L
Remote lock, two button YWX101230 requires programming by LR computer
Wiper/washer STC4016 STC1435
Seats left PRC8096
right PRC8095 Defender
Windows left rear door PRC5255 Cowl vent seals JAE000030
right rear door PRC5254
center console (x 4) AMR2496
sunroof PRC5255 YWB10032L YWB10027L
isolator switch AMR2497 Windshield, clear (no tint)
Spiral casette, cruise control YRC100350 MTC2864
Speed transducer YBE100540 Seal MUC3733
Brake light switch AMR2010
Relays yellow YWB10027L starter, a/c, ignition, alarm, fog, wash, seats, more
black (or green) YWB10032L wipers, cruise, more
Antenna
Defender XUC100850
Discovery 1 non power AMR3461 Disco 1 Mud Flaps
power STC8040 Front kit RTC6820P
Mirrors, Exterior Rear kit RTC6821P
Defender mirror head, flat glass ALR4626 CRD100690: back front Two flaps with hardware
mirror head, convex MTC5084
Discovery 1 left CRB108850 glass only CRD100690
right CRB108840 glass only CRD100660 Front right MXC7182PUB
Mirrors, Interior Front left MXC7183PUB
Discovery 1 Rear right MXC6730PUB
Manual dim STC4781 Rear left MXC6731PUB
Auto dim '94-97 AWR2146 Individual flaps
Auto dim, '98 CTB100130 includes map light

Visor Clips EGP100340LUM gray

Wiper Blades, Washers

Defender blades, front or rear DKC000110PMD
Discovery 1 '94-'97 front, both AMR1805
rear AMR1806
'98-'99 front left DKC100910
front right DKC100920
rear AMR1806 Disco jumbo
Washers Disco1 headlamp AMR1890 cupholders
windshield PRC7304 pair, fit to console:
rear PRC6496 tan STC53156SUC
gray STC53156LPW
Window Regulators Discovery 1 XD type hood blackout decal
Window regulators to VIN #SA137189 (to mid '95) STC7253
left front RTC3815 motor RTC3821
right front RTC3814 motor RTC3820
left rear RTC3817 motor RTC6642
right rear RTC3816 motor RTC6643
Window regulators from VIN #SA137190 (from mid '95 on)
left front CUH102310 motor CUR100450
right front CUH102300 motor CUR100440 STC2883
left rear STC2883 motor CUR100440
right rear STC2884 motor CUR100450
Bumper end caps: Discovery 1 Disco XD Front Bumper End Caps:
front left AWR2991PMDG
front right AWR2992PMDG use when removing front spoiler
rear left AWR2989PMDG to improve approach angle:
rear right AWR2990PMDG STC7258 left STC7259 right
 Defender, Discovery Books and Videos Page 13

Defender, Discovery Factory Repair Manuals

Defender '93-'95 LDAWMEN93
Discovery 1, '95-'98 LRL0079
Discovery 2, '99-'02 4.0 VDR100090
V8 Engine Manual LRL0164 3.5, 3.9, 4.2 engines only

Discovery 1 Owners Manuals

Owners wallet, as supplied with vehicle: inquire
Paperback reprint: specify year and model:
not all are currently available, all are out of print.

The Haynes Manual is for the more

advanced home mechanic. Profusely
illustrated, it covers most of the major
vehicle systems. While written for home Discovery Performance Portfolio
market trucks, most of the data applies A compilation of magazine articles and road
to NAS models as well. Just be sure to tests give a wealth of information for anyone
convert Imperial gallons to US! This book considering buying a used Disco. Contains
does assume you have some data, performance tables, specifications, and
mechanical knowledge. Hardback, comparison tests for models made between
profusely illustrated. '89 to '98 models. 1989-2000. Some of the info includes euro
Sorry, no gasoline Defender available. spec diesels. Softback, 140 pages.
3016 LR89PP

Operating Techniques
Off-Roader Driving by Tom Sheppard Working In The Wild (Manual for Africa)
Now in it’s third printing, Tom Sheppard’s
textbook is the best basic book for the New edition! Many techniques for planning
beginner. It talks about vehicle selection, off road excursions and operations in harsh
outfitting, driving techniques, expedition enviornments. Great stuff like human water
basics, vehicle recovery, and much more. consumption tables and heat indexes make
Covers many popular 4x4’s with a strong it a vital part of your toolbox.
emphasis on Land Rover, all years and
models. Packed with great details and info. Softback , 190 pgs.
Hardbound, color illustrations, data charts SMR684M1
and tables. LRO0444

Getting PREpared DVD Winching In Safety Getting Unstuck DVD

Bill Burke's video reference Small glovebox sized with Bill Burke
manual for getting yourself and paperback on the Great training film from Camel Trophy
your vehicle ready for off road proper winching and veteran Bill Burke. Shows you how to
travel. Food, tires, pets, camp- get out of common problems, and the
sites, it's all in here. Invaluable!
vehicle recovery
techniques. right way to use tools and recovery
"prepared-dvd"
SMR699M1 gear. DVD, 120 min. "unstuck-dvd"

Magazines, Videos Rovering Moab DVD Land Rover Monthly

Ride along as some 'flatlanders' The North American version
Land Rover try out some of Moab's most of the popular magazine.
Enthusiast famous trails, led by Bill Burke. Over 200 pages, hundreds of color
Discos, Range Rovers, Defenders, photos. Marque histories,
Magazine and Series III lighweights go trailing. expedition stories, and tech help,
Produced 14 times per year, plus news about Land Rover.
DVD, 60 min. "moabdvd"
generally monthly. Over 200 We often have the last several
pages, hundreds of color issues in stock, call for availability.
photos. Marque histories, Camel Trophy DVD The 'deal of the day' on the website
expedition stories, and tech usually announces each new issue.
help, plus news about Land 1988-1998
Rover. We usually stock the Defenders, Discos, lots
last several issues, call for of mud, and fast action in Rally Moab DVD
availability. this compilation from the The 2004 Land Rover National
The 'deal of the day' on the good old pre-politically
correct days. Great value!
Rally, with a wide variey of models
website usually announces and events, with the spectacular
each new issue. "ctdvd"
Utah and Colorado venues.
All videos in U.S. dvd-ntsc format. 35 min. "moab2004"

BP accepts Master Card, Visa, AmEx: order on line at landroverparts.us or call 800 554 4133
 Defender Gear and Accessories Page 14

'97 NAS D90 Rear Lenses

Red STC891 In stock!
Amber STC893 Clear STC894

Rear Fog Lamp As used on European

models, improves following traffic visibility
in bad weather. Brighter than stock taillight,
check local laws. PRC7254
Bull Bars:
Tread Plate Accessories 90 & 110 models
Euro style aluminum treadplate See our 'Offroad' section
accessories:
Fender tops GAL051
Sill plate D90 GAL057
Sill plate D110 GAL056
Rear corner plate GAL058

Steel replacement wheels

Raider step bar D90 GAL060 see page 5
D110 GAL064
Twin tube step D90 GAL054
D110 GAL053

Rock sliders:
'Offroad' section

IPF Lighting Kits

'Offroad' section
K&N Filters and Bridge Ladders
cleaning kits: page 1 Sand Ladders
in stock!

4.11 gears to improve

aceleration and compensate for big tires:
air lockers too! Page 5

NATO
jerrycans
Old Man Emu
and
5' Hi-Lift jacks suspensions
accessories:
and accessories: 'Offroad' section page 7
'Offroad' section
BP'S hours are 8-4, M-F, west coast time britpac@aol.com 800 554-4133 landroverparts.us