9870 Parts

WARNING:
THIS EQUIPMENT MUST BE CONNECTED TO A PROPERLY GROUNDED THREE (3)

WIRE OUTLET. FAILURE TO DO SO CREATES A POTENTIAL DANGER OF
ELECTRICAL SHOCK.
THE CIRCUIT TO WHICH THIS EQUIPMENT IS CONNECTED MUST BE CURRENT

PROTECTED BY A DEVICE WITH SUITABLE CURRENT INTERRUPTION CAPABILITY
AS REQUIRED BY UNDERWRITERS LABORATORIES, CANADIAN STANDARDS
ASSOCIATION, N.E.M.A. OR LOCAL CODE, WHICHEVER IS THE MOST
STRINGENT.
THIS EQUIPMENT MUST NOT BE OPERATED WITH SAFETY COVERS AND/OR

ELECTRICAL INTERLOCK SYSTEMS BY-PASSED OR MADE INOPERATIVE.
WHEN SERVICING THIS EQUIPMENT WITH COVERS REMOVED. EXPOSED

TERMINALS ARE AN ELECTRICAL HAZARD. CAUTION MUST BE EXERCISED.
WARNING:
THIS EQUIPMENT GENERATES, USES, AND CAN RADIATE RADIO FREQUENCY
ENERGY AND, IF NOT INSTALLED AND USED IN ACCORDANCE WITH THE
OPERATOR'S MANUAL, MAY CAUSE INTERFERENCE TO RADIO COMMUNICATIONS.
IT HAS BEEN TESTED AND FOUND TO COMPLY WITH THE LIMITS FOR A CLASS
"A" COMPUTING DEVICE PURSUANT TO SUBPART "J" OF PART 15 OF FCC
RULES WHICH ARE DESIGNED TO PROVIDE REASONABLE PROTECTION AGAINST
SUCH INTERFERENCE WHEN OPERATED IN A COMMERCIAL ENVIRONMENT.
OPERATION OF THIS EQUIPMENT IN A RESIDENTIAL AREA IS LIKELY TO
CAUSE INTERFERENCE IN WHICH CASE THE USER AT HIS/HER OWN EXPENSE,
WILL BE REQUIRED TO TAKE WHATEVER MEASURES THAT MAY BE REQUIRED TO
CORRECT THE INTERFERENCE.
IMPORTANT NOTICE:
THE INFORMATION CONTAINED IN THIS PUBLICATION IS STRICTLY
CONFIDENTIAL. NO PART OF THIS DOCUMENT MAY BE REPRODUCED, STORED
IN A RETRIEVAL SYSTEM, OR,TRANSMITTED, IN ANY FORM OR BY ANY MEANS,
ELECTRONIC, MECHANICAL, PHOTOCOPYING, RECORDING, OR OTHERWISE,
WITHOUT THE PRIOR WRITTEN PERMISSION OF A.B.DICK COMPANY. FURTHER,
THE CUSTODIAN OF THIS DOCUMENT SHALL ENSURE THAT NO PART OF THIS
DOCUMENT SHALL BE DISCLOSED OR PERMITTED TO BE DISCLOSED TO ANY
THIRD PARTY, OR USED FOR ANY THIRD PARTY, OR USED FOR ANY PURPOSE
OTHER THAN THAT FOR WHICH IT IS INTENDED WITHOUT THE PRIOR WRITTEN
PERMISSION OF A.B.DICK COMPANY.
NOTE:
USERS OF THIS EQUIPMENT SERVICE DOCUMENT ARE WARNED THAT A.B.DICK
SERVICE DOCUMENTS ARE DESIGNED TO BE USED IN CONJUNCTION WITH AN
A.B.DICK SERVICE TRAINING CLASS. AN UNTRAINED PERSON USING THIS
DOCUMENT, WITHOUT THE BENEFIT OF THE ACCOMPANYING TRAINING, COULD
INADVERTENTLY CAUSE DAMAGE TO THE EQUIPMENT AND/OR CAUSE INJURY TO
HIMSELF/HERSELF OR OTHERS. USERS OF THIS DOCUMENT ARE ADVISED THAT
A.B.DICK COMPANY SHALL NOT BE LIABLE FOR ANY PERSONAL INJURY OR
PROPERTY DAMAGE ARISING OUT OF THE USE OF THIS DOCUMENT, BY
UNTRAINED PERSONS.
MODEL 9865/69 & 9870 OFFSET DUPLICATOR
GENERAL INFORMATION
NOTE TO USERS OF CATALOG:
The part numbers for all difference in

electrical value, have been moved to the bottom
portion of that particular index page.
PARTS IDENTIFICATION AND ORDERING INSTRUCTIONS
I. Order Repair Parts by part number only. Do not order by figure and
index numbers.
II. It is not impossible to have two or more of the same index number with
different part numbers. In such cases, please read the full description
for your particular needs.
III. The following symbols and abbreviations are used consi_stently as aids in
identification:
A. Symbols
1. (*I Part of an assembly and not sold separately.

2. (***) Is used for all other pertinent remarks.
B. Abbreviations
1. O.S. = Operator Side

N.O.S. = Non Operator Side
:: I.D. = Inside Diameter
4. O.D. = Outside Diameter
5. O.A.L. = Overall Length
6. V. = Volts
7. Hz. = Cycles Per Second
8. Amp. = Amperes
TAELE OF CONTENTS
Figure Description Card Location
68A Air and Vacuum Valve Assembly (M-9870) O-66 B7
68 Air, Vacuum and Shuttle Valves O-66 B5
14 Aquamatic Control Shaft O-64 Cl3
14A Aquamatic Control Shaft (M-9870) O-64 Dl
12 Aquamatic Lockout Shaft O-64 c7
12A Aquamatic Lockout Shaft (M-9870) O-64 c9
10 Aquamatic - Part I O-64 Cl
11 Aquamatic - Part II O-64 c3
11A Aquamatic - Part II (M-9870) O-64 c5
82 Back Jogger Mechanism - Part I O-66 D7
83 Back Jogger Mechanism - Part II O-66 D9
88 Back Stop Chain Delivery O-66 E5
43 Blanket Cylinder - Part I O-65 Dl
44 Blanket Cylinder - Part II O-65 D3
39 Blanket Washer - Part I O-65 c7
40 Blanket Washer - Part II O-65 c9
42 Blanket Washer Pump O-65 Cl3
41 Blanket Washer Soleniod O-65 Cl1
54 Buckle Adjusting and Levers O-65 E9
46 Cam Shaft Assembly O-65 D7
69 Compressor Assembly O-66 89
72 Control Box and Cover D-66 Cl
73 Control Box Divider Assembly O-66 c3
76 Control Box Harnesses - Part I O-66 c9

TARE OF CONTENTS
77 Control Box Harnesses - Part II O-66 Cl1
75 Control Box P.C. Boards O-66 c7
74 Control Box Relay Bracket O-66 c5
78 Control Box Ribbon Cables O-66 Cl3
4 Control Panel O-64 B3
2 Cover Assemblies O-64 Al3
89 Cover and Frames - Chain Delivery O-66 E9
62 Delivery Roller and Stripper O-65 Fll
90 Dolly and Frame Assemblies O-66 El1
85 Dolly Raise Control O-66 D13
84 Dolly Raise Shaft Assembly O-66 Dll
45 Drive Shaft Assembly O-65 D5
38 Emergency Stop and Doubles Switches O-65 c5
16 Etcher Assembly - Part I O-64 D5
17 Etcher Assembly - Part II O-64 D7
15 Etcher Bottle and Actuator Shaft O-64 D3
18 Etcher Soleniod and Motor O-64 D9
56 Feed Mechanism and Power Link O-65 El3
55 Feed Solenoid and link O-65 El1
66 Feed Table and Paper Guides O-66 Bl
57 Feed Table Raising Mechanism O-65 Fl
53 Feed Table Release Lever O-65 E7
65 Frame - Base and Drive Motor O-66 Al3
36 Frames - Ink Head O-65 813
\
4-J
III
TABLE OF CONTENTS
36A Frames - Ink Head (M-9870) O-65 Cl
51 Frames - Mid Section O-65 E3
23A Form Roller - Lower (M-9870) O-64 E9
23 Form Rollers and Separator Shaft O-64 E7
238 Form Roller Separator Shaft (M-9870) O-64 El1
24 Form Roller I Solenoid Assembly O-64 Fl
23C Form Roller - Third (M-9870) O-64 El3
32A Gap Control - Master Cylinder (M-9870) O-65 B5
80 Gripper Bar and Chain Assemblies O-66 D3
63 Hold Down Roller Assembly O-65 F13
81 Idler Shaft Assembly O-66 D5
47 Impression Cylinder Assembly O-65 D9
50 Impression Cylinder Gap Control O-65 El ‘L-

48 Impression Cylinder Shaft and Support Arms O-65 Dll
49 Impression Latch and Feed Solenoid O-65 D13
19 Ink Feed Solenoid and Ductor Roller O-64 Dll
20 Ink Metering Assembly O-64 D13
21 Ink Roller Control O-64 El
21A Ink Roller Control (M-9870) O-64 E3
64 Jam Detector Assembly O-66 All
58 Main Tie Bar Assembly - Part I O-65 F3
59 Main Tie Bar Assembly - Part II O-65 F5
31 Master Cylinder Assembly O-65 All

31A Master Cylinder Assembly - Part I (M-9870) O-65 Al3
IV
TABLE OF CONTENTS
318 Master Cylinder Assembly - Part II (M-9870) O-65 Bl
37 Master Cylinder Latch O-65 c3
32 Master Cylinder Shaft and Support Arms O-65 B3

\
33 Master Ejector Assembly O-65 B7 \
\
34 Master Ejector Guide and Stripper O-65 B9 \
35 Master Ejector Solenoid Assembly O-65 Bll
25 Master Feed Table and Switch O-64 F3
26 Master Feeler Switch Assembly O-64 F5
28 Master Forwarding Unit - Part I O-64 F9
29 Master Forwarding Unit - Part II O-64 Fll
30 Master Forwarding Unit - Part III O-64 F13
27 Master Forwarding Solenoid O-64 F7
14 Master Load Solenoid O-64 Cl3
9 Master Receiving Tray O-64 813
86 Paper Guides - Chain Delivery O-66 El
1 Paper Guides and Mounting Bar O-64 All
52 Paper Height Adjustment O-65 E5
5 Receiving Tray Assembly O-64 85
7 Safety Guard - Aqumatic and Ink O-64 B9
6 Safety Guard - Blanket Cylinder O-64 B7
87 Safety Guard - Chain Delivery O-66 E3
88A Safety Guard - Chain Delivery (M-9870) O-66 E7
8 Safety Guard - Tray Delivery O-64 Bll
3 Solution Drain Kit O-64 Bl
V
MODEL 9865169 & 9870 OFFSET DUPLICATOR
I TABLE OF CONTENTS
I !’
/ Jre Description Card Location
I Sprocket Shaft and Paper Guides D-66 Dl

I i’ 7g
60 Sucker Foot Assembly O-65 F7
/ 67 Tubing O-66 83
61 Vacuum Make and Break Control O-65 F9
13 Waver,Oscillating and Rider Rollers O-64 Cl1

I
22 Waver Roller Assembly O-64 E5
,‘!
71 Wire Harnesses - N.O.S. O-66 813
70 Wire Harnesses - O.S. O-66 Bll
91 Worklight Assembly O-66 El3

Index Part MODEL 9865/9869 - Figure 1 Units
No. No. Description Per Assy.
073394 KNOB - Lock, l/4-28 x 518 . . . . . . . . . . . . . . . . . . . . . . . . (M-9870) 3

: 075890 KNOB - Lock, l/4-28 x l-1/32 . . . . . . . . . . . . . . . . . . . . . (M-9870)
3 075887 KNOB - Dual Micro Guide, 3/8-24 . . . . . . . . . . . . . . . . . . (;-;;w;!, :
4 150085 NUT - l/4-28 . . . . . . . . ..*...................*...... 1
5 194897 STUD - Adjusting . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . tMI9870) 1
075888 PLATE - Retainer . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . (M-9870) 1
9 100583 SCREW : ;/z-28 x l/2 . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
8 075884 PLATE Micro Guide . . . . . . . . . . . . . . . . . . . . . . . . (M-g870) (M-9870) :
075885 PLATE - N:O:: Micro Guide .*.....*.............. [;-;;w;{ ;
TO 007862 SHAFT - Micro'iuide . . . . . . . . . . . . . . . . . . . . . . . ...*... -
11 075883 BRACKET - Micro Guide Adjustment Assembly . . . . . . . . (M-9870)
12 100177 SCREW - Set, l/4-28 x l/2 . . . . ..‘........................ :
100579 PIN - Roll, ,199 0.0. x .640 O.A.L. . . . . .. . . . . . . . . .. . . . . . 1
:t 007661 PAPER WEIGHT - Standard .. . . . . . . . . . . . . . . . . . . . . . . . . . . . .. . . . . 1
14 007809 PAPER WEIGHT - Light Weight . .. . . . .. . . . . . . . . . . . . . . . . . . . . . . . 1
15 072511 SPRING - .250 O.D. x 1.125 O.A.L. .. . . . . . . .. . . . .. .. . .. .. . . .
196171 KNOB - Dual Micro Guide, 3/8-24 . . . . . . . . . . . . . . . . . . (M-9870) :
:7" 008038 BAR - Mounting, Long . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . ...*. 1
18 076893 STOP - Paper Guides . . . . . . . . . ..*............*.......*......
19 007689 PLATE - Center . . . . . . . . . . . . .. . . . . . . . . . . . . . . . . .. .. . . . . . . . . . . :
20 072292 NUT - Thumb, l/4-20 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . ...*. 2
073467 GUIDE - Back, Stock Retainer .**...*.......................
f: 073385 CLAMP - Adjusting . . . . . . . ..‘............................... 3'
23 073469 PLATE - Retainer, Spring . . . . . . . .. .. . . . . . . . . . . . . .. . . . . . .. . . 1
24 073472 SPRING - Guide Retainer . ..**..............................
25 014225 SCREW - 8-32 x l/4 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . :
26 111075 SCREW - l/4-28 x 718 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2
27 150085 NUT - l/4-28 . . . . . . . . . . . . . . . . . . . . . . . ..*....**..*.....*..... 4
28 072197 STUD . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . ..*..................... 1
29 195367 SPACER - 7/16 O.D. x .255 I.D. . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4
30 196231 ANCHOR - Spring, 1 15/32 O.A.L. . . ..**.....................
31 076890 PLATE - Side, O.S. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . :
32 111055 SCREW - lo-32 x 9/16 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4
33 192142 SPRING - 1.000 O.A.L. . . . . . . ..*............................
34 076889 PLATE - Side, N.O.S. . . . . . . . . . . . . . . ..*..................... :
35 195140 NUT - Adapter .. .. . . . . .. . . . . . . . . . . . . . . . . . . . . . . . . .. . . . . .. . . .
36 014807 NUT - l/4-28 . . . ..*.............***........................ :
37 076887 BRACKET - Stop . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1
073463 PLATE - Side Guide . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1
3"; 014171 SCREW - lo-32 X 3/4 . . . . ..**.......*.......................
40 073464 GUIDE - Side, Stock Retainer . . . . . . . . . . . . . . . . . . . . . . .. . . .. . . :
k-./’ Index Part MODEL 9865/9869 - Figure 2 Units
No. No. Description Per Assy
1 025522 COVER - Motor, Etcher ..................................... 1

2 025184 COVER ASSEMBLY - Ink, N.O.S. (M-9865/69) .................. 1
017539 COVER ASSEMBLY - Ink, N.O.S. ..................... (M-9870)
: 014311 SCREW - 8-15 X 518 ........................................ :
4 001631 SCREW - lo-32 X 7/16 (M-9865/69) .......................... 6
4 001259 SCREW - lo-16 X l/2 ..............................
017537 COVER ASSENBLY - Ink, 0.5. ........................ (M-g870)
........ :
z 017541 DECAL - Ink ............................................. 1
001884 NUT - Speed, #8 (M-9865169) .............................
: 101144 NUT - Speed, #lO ............................... (M-9870) 5
8 025175 COVER ASSEMBLY - O.S. (1st Design M-9865/69) .............. 1
087808 COVER ASSEMBLY - O.S. (M-9865/69) ......................... 1
: 087814 COVER ASSEMBLY - O.S. ............................ (M-9870)
9 017090 DECAL - Water Control ................................... :
025187 DECAL - Form Rollers (M-9865/69) ........................ 1
:: 017093 DECAL - Form Rollers ........................... (M-9870) 1
12 017018 DECAL - Feed (Aux.) On/Off, O.S. ........................ 1
13 017090 DECPL - Buckle .......................................... 1
14 017092 DECAL - Air/Vat. ........................................ 1
017605 DECAL - Paper hight Regulator ...........................
:z 025475 HARNESS - Feed, On/Off,Chute .............................. :
17 253002 SWITCH - Feed .............................................
18 253031 LENS - Cap, Feed .......................................... :
017528 COVER ASSEMBLY - Lower O.S. (1st Design M-9865/69) ........
:; 087830 COVER ASSEMBLY - Lower O.S. .......... (M-9865/69 & M-9870) :
20 016315 PANEL - Rear, Flat ........................................
21 101494 SCREW - l/4-28 X 518 ...................................... .:
101981 NUT - Speed, U Type .180 .................................. 2
‘i__i fS 101982 NUT - SPEED, U Type ,276 ..................................
24 196222 SCREW - Painted, lo-32 x 518 .............................. ;
25 100485 WASHER - LOCK, Countersunk #lO ............................ 8
26 017140 BRACKET ASSEMBLY - Switch, Chute .......................... 1
111070 SCREW - l/4-28 X 7116 Cnute ...............................
z 253472 SWITCH - 4PDT Momentary, Inch ............................. ;
29 253562 LENS CAP - RED ............................................ 1
253563 LAMP - 6.3 V. ............................................. , 1
33: 253561 HOUSING - Lamp ............................................ 1
32 025528 HARNESS - Inch, Inhibit ................................... 1
001631 SCREW - lo-32 X 7/16 ...................................... 3
:4" 025181 COVER ASSEMBLY - Top N.O.S. (1st Design M-9865/69) ........ 1
34 087809 COVER ASSEMBLY - Top N.O.S. (M-9865169) ................... 1
34 087811 COVER ASSEMBLY - Top N.O.S. ...................... (M-9870) 1
084126 DECAL - Form Roller .....................................
zz 013267 DECAL - Blanket Washer .................................. :
025536 COVER ASSEMBLY - Etcher, O.S. .............................
;z: 025188 DECAL - Inching ......................................... :
025459 HARNESS - Fwd/Rev,Switch (M-9865) ......................... 1
3"; 025364 HARNESS - Fwd/Rev,Switch (M-9869) .........................
40 083648 BRACKET - Angle .................................. (M-9870) :
41 017094 DECAL - Operation Control, (Not Illustrated) ..... (M-9870) 1
017172 PLUG - Hole 1" Painted, (Not Illustrated) ;
:: 022838 BRACKEl - Mounting, Alarm Light ..................
4
P_ 0 0 00 mm

No. No. Description Per Ass)
0 *** SOLUTION DRAIN KIT ACCESSORY ..............................

1 012962 HOSE .................................................... :
012961 ADAPTER -Hose ........................................... 1
: 001603 SCREW - lo-32 % 3/8 .....................................
4 014837 NUT - lo-32 ............................................. z
011411 COVER ASSEMBLY ..........................................
6" 100188 SCREW - 5-40 X 318 .................................... :
7 100335 WASHER - Lock, .136 I.D. X .255 O.D. X .023 ........... 2
8 101195 NUT - 5-40 ............................................ 2
9 080839 CLIP - Hose Retaining .................................
10 012963 BOTTLE - PLASTIC ........................................ :
11 011410 PUMP AND BASE ASSEMBLY ..................................
110246 SCREW - 8-32 X 5/16 ................................... :
:P 014811 NllT - 8-32 ............................................ 3
012959 PLATE ................................................. 1
:: 012958 COVER .................................................
100450 SCREW - lo-32 X 9/16 .................................. :
:; 001812 NUT - lo-32 ........................................... 4
012961 ADAPTER - Hose ........................................ 1
:I: 012960 HAND PUMP ASSEMBLY .................................... 1
20 013580 DIAPHRAGM ........................................... 1
013581 REGULATOR - Flow Control ............................
5: 193616 SCREW - lo-24 X .475 .................................. :
23 013582 BRACKET ............................................... 2
24 011409 BASE .................................................. 1
*** Kit Avaiable As 1-3691-C
6
1 016895 BRACKET - Hinge . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

001279 - #8 X l/2 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1:
: 025141 "L%:: - SWITCH (M-9865/69) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . ..
4 025357 SWITCH ASSEMBLY - Manual Over - Ride (M-9865/69) . .. . . . . . . . :
025358 SWITCH ASSEMBLY - Manual Print Control (M-9865/69) ... .....
; 025525 POTENTIOMETER ASSEMBLY - SPEED CONTROL (M-9865/69) ........ :
6 022797 SWITCH ASSEMBLY Speed (Not Illustrated) . . . . . . . . . . (M-9870) 2
7 025370 POTENTIOMETER ASSEMBLY - ETCHER CONTROL (M-9865/69) . ..... . 1
8 025363 HARNESS - Guard Reset (M-9865/69) .........................
022831 HARNESS - Guard Reset . . . . . . . . . . . . . . . . . . . . . . . . . . . . (M-9870) :
! 253551 SWITCH - Pushbutton, Lighted SPDT . . . . . . . . . . . . . . . . . . . . . . . . . 1
10 008156 PC BOARD ASSEMBLY . . . . . . . . . . . . . . . . . . . . . .. . . . . . . . . . . . . . . . . . . 1
11 014797 WASHER - Plain, .172 I.D. x .375 O.D. x .029 . . . . . . . . . . . . . . 3
12 001661 SCREW - 8-32 X 5/16 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3
13 025135 PANEL - Control (M-9865/69) . . . . . . . . . . . . . . . . . . . . . . . . .. .. . . .
13 022751 PANEL - Control . . . . . . . . . . . . . . . . . . . . . . . . . ..*...... :
14 017799 BRACKET - Hinge . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . (M-g870)
....... 1
025138 MEMBRANE - Switch Panel (M-9865/69) . . . . . . . . . . . . .. . . . . . . . . .
:z 022753 MEMBRANE - Switch Panel . . . . . . . . . . . . . . . . . . . . . . . . . . (M-9870) :
100228 NUT - 4-40 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4
:; 191800 WASHER - Plain, l/8 I.D. X 5/16 O.D. X l/32 . . . . . . . . . . . . . . . 4
18 101570 SCREW - 4-40 X l/2 . . . . . . . . . . . . . . . . . . . . . . . . . . . . ..*.........
19 025359 LCD ASSEMBLY . . . . . . . . . . . . . . . . . . . . . . . ..*.................... .y
20 025139 BEZEL - LCD . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
21 014507 RING - Retaining ( l/8 shaft ) . . . . . . . . . . . . . . . . . . . . . . . . . . . . :
22 025137 SHAFT - Pivot . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . ...*. 1
23 025136 COVER - Control Panel . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
025140 LABEL - Potentiometer (M-9865/69) . . . . . . . . . . . . . . . . . . . .. . . . . :
t: 022796 LABEL - Speed . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . (M-9870)
25 101758 FASTENER - Treelock . . . . . . . . . . .. . . .. . . . . . . . . . . . . . . . . . . . .. . . :
26 253471 KNOB (M-9865/69) . . . . . .. . . . . . . . . . . . . . . . . . . . . . . . . . . . . .. . . . . . 2
025417 NAME PLATE - 9865 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
f: 008145 NAME PLATE - 9869 . . . . . . . . . . . . . . . . . . . . . . . . . . ..*............ :
27 022777 NAME PLATE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . (M-9870) 1
28 001220 SCREW - lo-32 X 3J8 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4
017797 BRACKET - Pivot,Left . . . . . . . . . . . . . .. . . . . . . . . . . . . . . . . . . . . . . .
f; 017163 BRACKET - Pivot,Rihgt (Not Illustrated) ................... :
30 112652 SCREW - 8-32 X 9/16 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3
31 196262 SPACER . . . . . . . . . . . . . . . . . . . . . . . . . . . . ..*..................... 2
32 111054 SCREW - lo-32 X l/2 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2
33 025142 COVER - PC Board . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
34 150081 NUT - 8-32 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . :
35 016896 BRACKET - Cable . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . (M-9870) 1
253387 HOUSING - Socket, 4 Pin (M-9865/69) . . . . . . . . . . . . . . ..*......
z: 253383 HOUSING - Socket, 2 Pin . . . . . . . . . . . . . . . . . . . . . . . . . . (M-9870) :
37 253832 GUARD - Switch Protection, . . . . . . . . . . . . . . . . . . . . . . . (M-9870)
253830 CAP - Switch Lens, Green . . . . . . . . . . . . . . . . . . . . . . . . . (M-9870) 1
:
:: 253831 CAP - Switch Lens, Yellow . . . . . . . . . . . . . . . . . . . . . . . . (M-9870)
8
017676 RECEIVING TRAY ASSEMBLY ( 9865 ) .........................

072757 KNOB - Paper Back Stop and Guide ....................... ;
191297 WASHER - FIBER, .354 1.0, X 5/8 O.D. X l/8 ............. 3
014169 SCREW - l/4-20 X l/2 ................................... 2
014170 SCREW - l/4-20 X 7J8 ................................... 1
072767 PAPER GUIDE ASSEMBLY - R.H. ............................
072765 PAPER GUIDE ASSEMBLY - L.H. ............................ :
072763 BACK STOP - Paper ......................................
066238 FELT . Stripping ....................................... :
072544 SPRING . ,406 0.0. X 3.125 O.A.L. ...................... 1
001812 NUT . lo-32 ............................................ 1
022621 WASHER .. 197 I.D. X .500 O.D. X .094 .................. 1
072795 SCREW - lo-32 X 3J8 .................................... 1
001049 RING - Retaining, .227 O.D. X .027 .....................
006675 WASHER .. 253 I.D. X .500 O.D. X .020 .................. 1
072774 RAM TRUCK . Receiving Tray Ram ......................... 4
014703 WASHER - ,384 I.D. X .562 X .029 .......................
001047 RING - Retaining, .340 I.D. X ,027 ..................... :
072796 BUSHING ................................................ 1
072784 TRUCK AND LEVER ASSEMBLY ............................... 1
072775 CRANK AND LINK ASSEMBLY ................................ 1
007694 RAM - Receiving Tray ...................................
017677 RECEIVING TRAY ......................................... . :
010364 TRAY BAIL ................................................ . 1
10
025384 GUARD ASSEMBLY - Blanket (M-9865/69) ...................... 1

022834 GUARD ASSEMBLY - Blanket ......................... (M-9870:
101944 BUMPER .................................................. :
072258 DECAL - Warning .........................................
025387 SHAFT ASSEMBLY ............................................ :
000009 PIN - Taper, .094 O.D. X 314 O.A.L. ..................... 1
032868 PIN - Roll, l/8 O.D. X 7116 O.A.L. ...................... 1
195146 SPACER - .752 O.A.L. ......................................
001060 RING - Retaining, .208 I.D. ............................... :
111006 SCREW - 4-40 X 9/16 ....................................... 2
253545 SWITCH - Micro, SPDT ...................................... 1
006917 INSULATION - Switch .......................................
190555 NUTPLATE . 4-40 ........................................... :
001594 SCREW - l/4-28 X l/2 ......................................
001555 SCREW - lo-32 X l/2 ....................................... :
025386 BRACKET - Switch ..........................................
150083 NUT - lo-32 ............................................... :
150085 NUT - l/4-28 .............................................. 1
12
~~~~
Index
1
No.
Part
No.
025377
010411
MODEL
GUARD - Aqumatic,
GUARD - Aqumatic
986519869
M-9865169
- Figure
Description
7
..............................
................................. (M-9870
Units
Per Assy
:
1
: 195145 SLEEVE ...................................................
111070
150085
SCREW . l/4-28 X J/16 ....................................
NUT - l/4 X 28 ...........................................
5
: 2
5 010378 BRACKET - O.S. ...........................................
010379 BRACKET - N.O.S. (Not Illustrated) ............... (M-9870 :
6” 018314 SHAFT - Guard ............................................ 1
001060 RING . Retaining, .208 I.D. ..............................
: 018151 GUARD - Ink, M-9865/69 ................................... :
8 010423 GUARD - Ink ...................................... (M-9870
076897 DECAL .................................................. :
YO 001129 SCREW - 6-32 X 5116 ...................................... 2
11 025378 COVER ASSEMBLY - Switch, M-9865/69 .......................
11 010388 COVER ASSEMBLY - Switch .......................... (M-9870 :
001543 SCREW - 8-32 X 3116 ...................................... 2
:P 025380 BRACKET - Switch, M-9865/69 .............................. 1
13 010405 BRACKET - Switch ................................. (M-9870 1
14 001073 RING . Retaining, .5JJ I.D. ..............................
15 -fmm39-’ CAM ASSEMBLY . Guard ..................................... :
014921 PIN . Roll, l/8 X J/8 ....................................
:; 190555 NUTPLATE - 4-40 M-9865/69 ................................ :
190731 NUTPLATE - 6-32 .................................. (M-9870 1
:: 190557 INSULATOR . M-9865169 .................................... 1
18 010342 INSULATOR ........................................ (M-9870
253545 SWITCH - Micro, SPDT M-9865169 ........................... 5
:3 253822 SWITCH . Micro, SPDT ............................. (M-9870
20 111011 SCREW - 4-40 X l-1/8 M-9865/69 ........................... c
20 101983 SCREW - 6-32 X l-518 ............................. 3
21 016197 SUPPORT - Guard .................................. [1%- 2
14
Index
No.
Part
No.
101494
016318
MODEL 986519869 - Figure
Description
8
SCREW - l/4-20 X 518 .....................................

GUARD . Tray .............................................
Units
Per Assy
2
I
076898 DECAL .................................................. :
150085 NUT - l/4-28 ............................................. 1
100657 SCREW - lo-32 X 518 ......................................
001575 SCREW - lo-32 X 5116 ..................................... :
014248 NUT - lo-32 .............................................. 2
072051 SHIELD ................................................... 1
111058 SCREW - lo-32 X 718 ...................................... 1
076869 GUARD - Rear ............................................. 1
111054 SCREW - lo-32 X l/2 ...................................... .
101976 SCREW . l/4-20 X 314 ..................................... . :
025472 COVER ASSEMBLY - Harness ................................. . 1
111034 SCREW - 8-32 X 318 ....................................... . 4
025470 GUARD - Delivery Roller .................................. . 1
074717 STUD ..................................................... .
150083 NUT . lo-32 .............................................. . :
025411 GUARD . Impression ........................................ 1
111060 SCREW - lo-32 X 1 l/8 .................................... . 2
015490 WASHER . .190 I.D. X 5/8 0.0. ............................. 2
076835 CATCH - Magnetic ..........................................
073544 SPACER .................................................... ;
014808 NUT - l/4-28 .............................................. 2
025423 BRACKET ASSEMBLY - Switch .................................
010402 ACTUATOR ASSEMBLY - Impression Guard ...................... :
032868 PIN - ROLL, l/8 X 7116 O.A.L. ...........................
000009 PIN - Taper . 110 O.D. X 3/4 O.A.L. ...................... :
190555 NUTPLATE - 4-40 ...........................................
111006 SCREW . 4-40 X 9/16 ....................................... :
253545 SWITCH - Micro, SPDT ......................................
006917 INSULATION - Switch ....................................... :
025474 COVER - Harness ...........................................
111055 SCREW - lo-32 X 9/16 ...................................... :
16
Index Part MODEL 986519869 - Figure 9 Units
1 025412 TRAY BAIL ASSEMBLY .......................................

014507 RING - Retaining, .095 I.D. X .019 .....................
5 001747 WASHER - . 128 I.D. X .375 O.D. X .029 ..................
4 072756 STUD - Shoulder ........................................
5 025414 BRACKET - Tray Bail ....................................
025413 TRAY BAIL ..............................................
! 025406 TRAY ASSEMBLY - Master Receiving ( M-9865 ) ..............
072757 KNOB ...................................................
tz 191297 WASHER - .256 I.D. X .625 O.D. X .063 ..................
10 014169 SCREW - l/4-20 X l/2 ...................................
072763 BACKSTOP ...............................................
:: 101760 SCREW . 8-32 X 7/8 .....................................
13 025408 SPACER - Flanged .......................................
025409 TIE ROD ................................................
:i 111034 SCREW - 8-32 X 318 .....................................
16 064764 PIN ....................................................
17 025407 TRAY - Master Receiving ( M-9865 ) .....................
18
*** BOTTLE ASSEMBLY - Repellant . . . . . . . . . . . . . .. . . . . . . . . . . . . . . . . 1

: 012141 BOTTLE - Repellant . . . . . . . . . . . . . . . . . . . ..‘................
3 011747 VALVE ASSEMBLY - Repellant . . . . . . . . . . . .. . . . . . . .. . . . . . . . . . :
4 014507 RING - Retaining, .095 I.D. X .019 . . . . . . . . . . . . . . . . . . . . 2
073308 SPRING - Special . . . .. . . . . . . . . . . . . . . . . . . . . . . .. . . . . . . . . .
6" 040868 SEAL - Bottle Cap . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . :
7 080536 PIN - Valve . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1
017820 CAP - Bottle . . . . . . . . . . . . . . . . . . . . .. . . . . . . . . . . . . . . .. . . . .
: 080583 WASHER - Bottle Cap . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . :
10 025244 TROUGH ASSEMBLY - Aquamatic, (M-9865/69) .................. 1
007653 TROUGH ASSEMBLY - Aquamatic . . . . . . . . . . . . . . . . . . . . . . (M-9870) ;
:: 013820 KNOB - O.S. (M-9865/69) .. .. . . . .. . . . . . . . . . . . . . . . . . . . . . . . . . .
14 080581 KNOB . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . (M-9870) 2
15 012673 KNOB - N.;;;;o;M-9865/69) .. .. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1
007668 ROLLER Rubber (M-9865/69) .. . . . . . . .. . . . . . . . . . . . . . 1
:: 007859 ROLLER - Ductor: Stainless Steel . . . . . . . . . . . . . . . . . (M-9870) 1
17 014518 RING - Retaining, Plastic, .389 I.D. . . . . . . . . . . . . . . . . . . . . . .
080504 HOUSING - Roller Bearing .. . . . . . . . . . . . . . . . . . . . . . . . . . .. . . . . . I
:; 014372 SCREW - SET, 10 - 32 X l/4 . ..*............................ 4
080505 BEARING - Roller . . . .. . . .. . . . . . . .. . . . . . . . . . . . . . . . . . . . . . .. . .
f! 080539 CARRIER ASSEMBLY - O.S. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . :
22 080541 CARRIER ASSEMBLY - N.O.S. . . .. . . . . . . . . . . . . . . .. . . . . . .. . . . . . . 1
001416 BUSHING - .504 I.D. X .627 O.D. . . . . . . . . . . . . . . . . . . . . . . . . .
;4" 064059 ROLLER . . . . . . . . . . . . . . .. . . . . . . . . . . . . . . . . . . .. . . . . . . . . .. . . .. f
001096 RING - RETAINING, .198 I.D. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2
5: 073542 SPRING - Tension, 1.312 O.A.L. . . . . . . . . . . . . . .. . . . . . . .. . . . . . 2
073540 SPRING - COMPRESSION, 1.500 O.A.L. . . . . . . . . . . . . .. . . . . . . .. . . 2
;; 007684 TIE BAR - Carrier . . . . . . . . . . . . . . . . . ..*..................... 1
29 191586 HOSE - Drain, Trough . . . . . . . . . . . . . . . . . . . . . . . . . . . . . (M-9870) 1
*** Not Salable As An Assembly
20
7
013421 FRAME ASSEMBLY . O.S. ..................................... 1
; 013386 PLATE - Frame, O.S. .....................................
001099 RING - Retaining, .283 I.D. ............................. :
t 080524 SCREW - Trough Mounting ................................. 2
s
7
012422
001080
025381
GEAR ASSEMBLY
RING . Retaining,
FRAME ASSEMBLY
- Ductor
. N.O.S.
.302 I.D.
..................................
.............................
...................................
f
1
8 025382 PLATE - FRAME, N.O.S. ................................... 1
9 082050 GEAR - Drive ............................................ 1
10 064189 SCREW . 8-32 X 5/32 ..................................... 1
001750 WASHER . .328 I.D. ......................................
:: 004074 WASHER - .320 I.D. ...................................... :
001772 WASHER - Spring, .328 I.D. ..............................
:1 111089 SCREW - 5/16-24 X 518 ..................................... :
15 111073 SCREW - l/4-28 X 5/8 ...................................... 4
16 150085 NUT - l/4-28 .............................................. 4
17 191173 rlASHER - .255 I.D. ........................................
003578 NUT . l/4-20 .............................................. :
E 191384 WASHER - Special, .255 I.D. ............................... 1
ff 025247
080591
014372
ROLLER - Repellant
HOUSING - Repellant
........................................
Roller Bearing
SCREW . Set, lo-32 X l/4 ..................................
........................
1
1
2
f5 080505 BEARING - Roller .......................................... 2
080599 GEAR - Repellant Roller ................................... 1
f: 014390 SCREW - Set, l/4-28 X If4 ................................. 2
26 017707 SHAFT ASSEMBLY - Aquamatic Control ........................
27 195396 PIN - Taper, .097 0.0. .................................. :
28 001978 PIN - Roll, .135 O.D. ................................... 1
011371 KNOB - Control Lever ...................................... 1
5: 072052 SPRING - Lock ............................................. 1
22
Index Part MODEL 9870 - Figure 11A Units
1 007966 FRAME - N.O.S. . . . . .. . . . . . . . . . . . . . . . . .. . . . . . . . . . . . . . . . . . . . . 1

2 010148 FRAME - O.S. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1
191384 WASHER - .255 I.D. . . . . . . . . . . . . . ..*........................
: 003578 NUT - l/4-20 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .. . . . . . 5
001099 RING - Retaining, .283 I.D. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
2 080524 SCREW - Shoulder .,....................,................... ;
7 012422 DUCTOR GEAR ASSEMBLY . . . . . . . .. . . . . . . . . . . . . . . . . . . . . . . .. . . . . . 2
001772 WASHER - Spring, .382 I.D. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
f 082050 GEAR . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . ...* :
001750 WASHER - .328 I.D. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
:; 004074 WASHER - 9/16 I.D. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . :
064189 SCREW - Lock . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
:5 080505 BEARING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .. . . . . . . . . . . . :
14 001080 RING - Retaining, .302 I.D. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
014390 SCREW - Set, l/4-28 x l/4 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . :
:: 080599 GEAR . . . . . . . . . . . . . . . . . . . ..*................................
17 007856 ROLLER - Rubber . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . :
080591 HOUSING - Bearing . . . . . . . . . . . . . . . . .. . . . . . . . . . . . . . . . .. . . . . . .
:: 014372 SCREW - Set, lo-32 x l/4 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . :
20 080979 SHIELD - Aquamatic, . . . . . . . . . .. . . .. . . . . .. . . . . . . . . . . . . . .. . . . 2
195086 WASHER - Stainless Steel, .513 I.D. x 1.000 O.D. . . . . . . . . . .
:: 195087 WASHER - Stainless Steel Spring, .520 I.D. . . . . . . . . . . . . . . . . ;
23 101870 RING - Retaining, Stainless Steel ,456 I.D. . . . . . . . . . . . . . . .
24 111073 SCREW - l/4-28 x 518 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5
25 111074 SCREW - l/4-28 x 314 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
26 150085 NUT - l/4-28 . . . . . . . . . . . . . . . . . . . . . . . . ..*...................
24
Index
No.
1
Part
NO.
031307
001812
SPRING
MODEL 9865/9869
- .222 0.0. X ,656 O.A.L.

- Figure
Description
12
X .020 ..................
NUT - lo-32 ..............................................
Units
Per Assy
2
1
I.
5 001702 WASHER - .195 I.D. X .500 O.D. X .D31 .................... 2
004256 SPRING - Commpression, .26D O.D. X .750 O.A.L. X ,026 ....
z 014515 RING - Plastic ........................................... :
075058 PIN - Solenoid ........................................... 1
f 075645 ROD - Plunger ............................................
100820 SCREW . 6-32 X l/4 ....................................... :
: 100369 SCREW - 6-32 X 7116 ...................................... 1
100483 CLAMP - Cable ............................................ 1
:I) 075039 SOLENOID . 120 V.A.C. 50/60 HZ. .......................... 1
001729 WASHER . LOCK, #6 ........................................
:: 193601 SCREW - Shoulder ......................................... z
14 008024 TIE BAR .................................................. 1
111077 SCREW - l/4-28 X 1 l/4 ...................................
:i 150085 NUT - l/4-28 ............................................. :
17 007582 REST ASSEMBLY . Roller ...................................
014350 SCREW - lo-32 X 5/16 ..................................... 1:
:: 021861 WASHER - 196 I.D. X .437 0.0. X .047 .............................................
20 073524 SLIDE - Lickout ... .. ..... ..... .. 4
21 075643 SPACER - .400 I.D. X .625 O.D. X .406 ....................
017793 SHAFT ASSEMBLY - Ductor Lockout .......................... :
2'3 101086 SCREW - Button Hd., l/4-28 X 3/4 .........................
24 111074 SCREW - l/4-28 X 314 ..................................... :
084418 BRACKET - Solenoid .......................................
;: 075644 STUD - Spring ............................................ :
27 014808 NUT . lo-32 .............................................. 1
-26
Index
No.
Part
No.
193601 SCREW - Shoulder,

MODEL 9870 - Figure
Description
5116-24
12A
................................
Units
Per Assy
1
.
3
:. 150085 NUT . l/4-28 ............................................. 6
3 078628 BRIDGE - Ink, N.O.S. .....................................
4 100815 SCREW - l/4-28 x l-1/4 ................................... . :
100653 SCREW - l/4-28 x 314 ..................................... . 2
z 014234 SCREW - l/4-28 x 1.000 ................................... . 2
7 078638 SLIDE . Adjusting ........................................ . 2
8 078669 LEVER ASSEMBLY ........................................... .
9 021861 WASHER . .196 I.D. x .437 O.D. ........................... :
10 014350 SCREW - lo-32 x 5/16 ..................................... . 4
11 014372 SCREW - Set, lo-32 x l/4 ................................. . 1
12 063206 COLLAR ................................................... . 1
082421 LEVER - Toggle ........................................... 1
:1 014745 WASHER - Spring, .342 I.D. x .630 O.D. ................... .
063087 SCREW - Shoulder, lo-32 .................................. . :
E 195681 SPACER ....................................................
001060 RING - Retaining, .208 I.D. .............................. . :
:; 078646 STOP . Lever ............................................. . 2
195686 STUD - lo-32 ..............................................
:: 100814 SCREW - l/4-28 x 1 l/2 .................................... :
21 078626 BRIDGE - Ink O.S. ...................................... .
22 078660 STUD - Pi vot . ‘5116-24 .................................... . :
23 014808 NUT . lo-32 .............................................. .
24 017704 LEVER ASSEMBLY ............................................ :
011371 HANDLE .................................................. 1
E 072052 LOCK - Spring ...........................................
27 001095 RING . Retaining, .245 I.D. ............................... :
28
Index
:
No.
Part
No.
073011
000014
COUPLE ASSEMBLY
PIN . Tapper,
MODEL 9865/9869 - Figure
Description
- Waver Roller
13
...........................
.147 O.D. X 1.127 ........................
Units
Per Assy
:
I.
*073014 ROLLER - Couple ........................................
t *073012 SHAFT - Couple ......................................... :
5 084413 GUIDE - Waver Roller ..................................... 1
111073 SCREW - l/4-28 X 5/8 ..................................... .
; 150085 NUT - l/4-28 ............................................. . :
8 080295 BRACKET - Spring Guide ................................... .
9 084412 GUIDE - Waver Roller ..................................... . :
101086 SCREW . Button Hd., l/4-28 X 3/4 .......................... 1
g 111074 SCREW - l/4-28 X 3/4 ......................................
073338 SPRING - Compression, .562 O.D. X 1.265 O.A.L. X .059 .... . :
13 007568 ROLLER ASSEMBLY - Ink & Repellant Waver, Nylon (M-9865/69), 1
194800 SCREW - l/4-28 X 12.5 O.A.L. ............................ 2
:z 001048 RING - Retaining External, .463 I.D. X .037 ............. 2
16 196475 NUT . Special Self locking l/4-28 ....................... 2
17 007569 SHAFT - Nylon Waver (M-9865/69) .........................
007852 SHAFT - Rubber Waver ........................... (M-9870: :
:: 076194 CAP ..................................................... 2
190387 BUSHING - Flanged Cap .................................
:x 007570 ROLLER - Ink and Repellant Waver, Nylon (M-9865/69) ..... :
20 008026 ROLLER - Transfer, Rubber ...................... (M-9870) 1
21 007576 ROLLER ASSEMBLY - Oscillating Rider .......................
22 001804 NUT . lo-32 ............................................. :
23 073193 PIN . Centralizing Screw, (M-9865/69) ................... 2
23 195684 PIN - Special .................................. (M-9870) 2
014390 SCREW - Set, l/4-28 X 1 l/4 .............................
5: 196475 NUT - Special Self Locking l/4-28 ....................... %
26 007580 TIE ROD .................................................
27 080694 PLUG .................................................... :
28 001497 BUSHING - .504 I.D. X .629 O.D. X .625 ................ 2
007581 SHAFT ................................................... 1
Pi 014523 RING - Retaining Internal, 2.600 O.D. X .081 ............
31 080698 GUARD - Splash .......................................... :
080263 CAP ..................................................... 1
2s 080699 BALL - .375 O.D. ........................................ 1
34 080695 PLUG AND CAM ASSEMBLY ..................................... 1
007577 ROLLER - Oscillating Rider ..............................
3365 001778 RING - Retaining External, .214 I.D. X .027 ............... 1:
37 073004 BUSHING - Special .........................................
38 001207 SCREW - Set, 8-32 X 3116 .................................. 2
073152 COLLAR ....................................................
:: 007547 ROLLER - Rider, Rubber .................................... z
087496 LEVER AND SHAFT ASSEMBLY - Operating ......................
:: 001812 NUT - lo-32 ............................................. :
43 001702 WASHER - .195 I.D. X .500 0.0. X .029 ...................
073339 SCREW . Eccentric, 10 . 32 .............................. :
tz 192900 PIN . Tapper, .142 O.D. X .750 .......................... 2
46 *073116 LEVER ................................................... 1
*080297 LEVER ................................................... 1
t; 080298 SCREW - Shoulder, lo-32 .................................
49 080299 TRUCK .................................................... 2’
101051 NUT - lo-32 .............................................
55: *080317 SHAFT ..................................................... 1’
52 073108 BRACKET ASSEMBLY .......................................... 1
192766 HlASHER - .385 1.0. X .750 O.D. X .090 .....................
:: 111076 SCREW . l/4-28 X 1.000 .................................... f
55 111079 SCREW . l/4-28 X 1.250 .................................... 1
56 111077 SCREW - l/4-28 X 1.375 ....................................
57 073234 BRACKET - ROLLER .......................................... :
*
lot Procurable Separately
30
Part MODEL 986519869 - Figure 14 Units
No. Description Per Assy
025249 ECCENTRIC SHAFT - Aquamtic Control ....................... 1

100400 PIN - Roll, ,135 O.D. X 9/16 .............................
073250 LEVER ASSEMBLY - Operating, N.O.S. ....................... :
073248 LEVER ASSEMBLY - Operating, O.S. ......................... 1
014605 BUSHING - .566 I.D. X ,691 O.D. X .750 ................. 2
190103 TRUCK .................................................. 2
190118 SCREW - Eccentric ...................................... 2
014808 NUT - lo-32 ............................................
040782 SPRING - Tension, .318 O.D. X 1 7/32 O.A.L. X .038 ....... %
195137 STUD . Bushing ...........................................
043097 WASHER - Lock, .440 I.D. X .750 O.D. X .059 .............. :
014805 NUT - 7/16-20 ............................................
001094 RING . Retaining External, .394 I.D. X .044 .............. :
012268 PLATE ASSEMBLY - Base ....................................
001980 PIN - Roll, .135 O.D. X .640 ........................... :
001095 RING . Retaining External, .245 I.D. X .027 ..............
192084 STUD - Base Plate ........................................ :
192135 SPRING - Compression, .299 O.D. X 1.000 O.A.L. X .024 .... . 1
012270 SHAFT GEAR AND PLATE ASSEMBLY ............................
012266 PLATE ASSEMBLY ......................................... . :
*012261 GEAR ................................................... .
*012260 SHAFT .................................................. . :
014902 PIN . Taper, .llO O.D. X .750 .......................... . 1
001990 PIN - Roll, .135 O.D. X .500 ........................... . 1
014808 NUT . lo-32 .............................................. .
012095 KNOB AND SPRING ASSEMBLY ................................. . :
001289 SCREW . 8-32 X I/4 ....................................... .
025238 CONTROL KNOB ASSEMBLY ..................................... :
039642 RING - Vinyl, .135 I.D. ...................................
196247 SCREW - Special, lo-32 X l-1/8 ............................ 1”
012722 CAM ASSEMBLY - Load .......................................
192202 WASHER - ,385 I.D. X ,625 X .OlO .......................... :,R
192087 SPRING - Compression, .460 O.D. X 1.250 O.A.L. X .026 .....
190394 SPACER - .510 I.D. X .625 O.D. X .290 O.A.L. .............. :
101558 RING . Retaining External, .296 I.D. X .037 ............... 1
025346 SOLENOIN ASSEMBLY - 115 V.A.C. 50/60 HZ. ..................
192088 PIN . Solenoid Drive ...................................... :
001681 SCREW - 6-32 X l/4 ........................................ 4
012972 BRACKET - Solenoid Mounting ............................... 1
001567 SCREW - I/4-28 X 318 ...................................... 2
* Not Procurable Separately

Index
No.
Part
No.
014793 WASHER - Friction,

MODEL 9870 - Figure
Description
17/64 I.D.
14A
............................
Units
Per Assy
2
.
3
001080 RING - Retaining, .302 I.D. ..............................
7 150085 NUT . l/4-28 ............................................. :
9 016275 LEVER ASSEMBLY - Micro Adjust ............................
072052 LOCK - Spring .......................................... :
:: 011371 HANDLE - Brown ......................................... 1
12 007662 ECCENTRIC SHAFT AND PINION ASSEMBLY ......................
13 000006 PIN - Taper, .582 O.A.L. ............................... :
14 *073246 GEAR - Eccentric Shaft .................................
*007663 SHAFT . Eccentric ...................................... :
:: 111068 SCREW - l/4-28 x 5/16 .................................... 2
040782 SPRING - Tension, ,318 O.D. x l-7132 O.A.L. .............. 2
:; 073252 BUSHING - Eccentric Shaft ................................
19 073248 LEVER ASSEMBLY . O.S. .................................... . :
20 073250 LEVER ASSEMBLY - N.O.S. .................................. . 1
21 071567 LEVER - N.O.S. ......................................... .
22 071566 LEVER - O.S. ........................................... . :
23 014605 BUSHING . .566 I.D. x .691 O.D. x .750 O.A.L. ........ . 1
057507 RIVET .................................................. . 1
I! 070125 TRUCK ...................................................
26 014248 NUT - Lock, lo-32 ...................................... . :
190118 STUD - Eccentric ........................................
5: 190103 TRUCK ................................................... :
30 001094 RING . Retaining, .394 I.D. ...............................
014805 NUT - 7116-20 ............................................. :
:: 043097 WASHER - .440 I.D. ........................................ 1
33 193606 STUD ...................................................... 1
021203 WAShER - .255 I.D. x .500 O.D. ............................
:“5 196666 SCREW - Adjusting ......................................... :
36 014504 RING - Retaining, .146 I.D. x .027 ........................
37 196664 WASHER - Spherical ........................................ :
001742 WASHER - Spring, 13/16 I.D. x .500 O.D. ...................
z: 016271 LEVER ASSEMBLY - Gear ..................................... :
154078 NUT . Lock, l/4-28 ........................................ 1
:: 193549 WASHER - Spring, .266 I.D. x .557 O.D. ....................
191384 MASHER - .260 I.D. x .750 O.D. ............................ 2’
t3’ 196662 STUD ......................................................
196663 STUD ...................................................... :
006776 WASHER - Plain, 3/16 I.D. x 318 O.D. x 3164 ............... 1
34
012418 BEARING BLOCK ............................................

: 100871 NUT - l/4-20 ............................................. :
025240 ACTUATOR SHAFT ASSEMBLY - Etch ...........................
43 012575 KNOB ................................................... :
*025241 SHAFT ..................................................
; *012798 LINK ................................................... :
100554 PIN - Spirol, .136 O.D. X .760 ......................... 3
; 130033 SCREW - Set, 8-32 X l/4 ................................ 2
9 *012414 ARM .................................................... 2
10 192159 SPRING - Compression, ,115 O.D. X .750 O.A.L. X .014 ...
012577 PIN - Detent ........................................... 2’
:: 012576 SCREW - Detent .........................................
13 *** BOTTLE ASSEMBLY - Etch ................................... :
012141 BOTTLE .................................................
:: 080583 GASKET ................................................. :
011203 VALVE ASSEMBLY .........................................
:; 014507 RING - Retaining External, .095 I.D. X .015 .......... :
18 040868 SEAL ................................................. 1
017820 CAP ..................................................
:x 192132 SPRING - Special ..................................... :
21 *012375 TUBE - Valve ......................................... 1
22 100878 PIN - Roll, .264 O.D. X 1.500 ........................ 1
23 012376 PIN VALVE ............................................ 1

36
025056 ETCHER ASSEMBLY . . . . . . . . . . . . . .. . . . . . . . . . . . . . . . . . .. . . . . . . . . . 1

: 025067 ROLLER ASSEMBLY - Wetting . . . . .. . . . . . . . . . . . . . . . . . . . . . . . . .
*025068 ROLLER - Wetting .. . . . . . . . .. . . . . . . . . . . . . . . . . . . . . . .. . . . . :
: *012367 GEAR - 22 Teeth . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
000008 PIN - Taper, ,095 O.D. X .697 . . . . . . . . . . . . . . . . . . . . . . . . . :
I: *012368 GEAR - 44 Teeth . .. . . . . . . . . . . . .. . . . . . .. . . . . . . . . . . . . . . . . 1
9 000009 PIN - Taper, .llO O.D. X .750 . . . . . . . . . . . . . . . . . . . . . . . . .
10 013391 BRACKET ASSEMBLY - Etcher, N.O.S. . . . . . . .. . . . . . . .. .. . .. . . :
11 013393 BRACKET ASSEMBLY - Etcher, O.S. . . . . . . . . . . . . . . . . . . . . . . . . . 1
012344 ARM ASSEMBLY - Etcher, N.O.S. . . . . . . ..*..................
:3 012341 ARM ASSEMBLY - Etcher, O.S. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . :
14 012697 TRUCK . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
100892 RING - Retaining External, .245 I.D. X .029 . . ..a...... :
:: 111052 SCREW - lo-32 X 5/16 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4
17 012386 SCREW - Special .. . . . .. . . . . . . . .. .. . . . . . . . . .. .. . . . . . . . . . . . 2
012352 ARM ASSEMBLY - Carrier . . .. . . . . . . . . . . . . . . . . . . .. . . . . . . . . . .
:: 001404 BUSHING - .379 I.D. X .504 O.D. X ,500 . . . . . . . . . . . . . . . . :
20 025059 ROLLER ASSEMBLY - Etch . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1
*025060 ROLLER - Etch . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
5: *012371 GEAR - 28 Teeth .. . . . . . . . . . . . . . . . . . . . . . . . . . . .. . . . . . . . . . :
23 192129 BUSHING - Flanged . . . . . . ..*............................
001080 RING - Retaining External, .302 I.D. X .036 . . . . . . . . . . . :
2’: *** COVER - Etch Roller . . . . .. . . . . . . . . . . . . . . .. . . . . . . . .. . . .. . . . .
26 025071 TUBE - Etch Cover Mounting . . . . . . .. . . . . . . . . . .. .. . . . . . . . . . . . :
*** Not Procurable Separately

*** Supply Number 4-4061 1.5 DIA. X 13.0 ( PK 6 )
38
Index
1
No.
Part
No.
025056 ETCHER ASSEMBLY

Description
17
. . . . . . . . . . . . . . . . . . .. . . . . . . . .. . . . . . . . . . . . . .
Units
Per Assy
1
.
1
2 011205 CARRIER ASSEMBLY - N.O.S. . . . .. . . . . . . . . . . . . . . . .. . . . . . . . . 1
012347 CARRIER ASSEMBLY - O.S. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
: 192130 BUSHING - Flanged . . .. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . :
5 025070 TIE BAR ................... . ............................
6 012378 CLIP . Spring ............. . ............................ H
193035 SPRING - Tension, .406 O.D. X 1.546 O.A.L. X .041 ......
: 014807 NUT . l/4-28 .............. . ............................ :
9 012493 PLUNGER AND HOUSING ASSEMBL ........................... 2
10 *012382 KNOB AND PLUNGER ASSEMBLYY ............................
11 014973 PIN - Roll, ,069 O.D. X ,327 ....................... :
12 *012383 HOUSING .................. ............................
13 192133 SPRING - Compression, .277 O.D. X 37164 O.A.L. X .022 :
14 192125 WASHER - .191 I.D. X .312 0.0. X .OlO ................
15 012380 STUD ................................................... :
025064 SPONGE ................................................. 1
:; 011206 RETAINER - Sponge ......................................
012379 KNOB ................................................... :
:s 025057 TRAY - Etch ............................................
20 025065 TIE ROD ................................................ :
111052 SCREW - lo-32 X 5/16 ................................... 2
I: 025062 PAN - Drip ............................................. 1
23 011207 CAP - O.S. .............................................
24 011208 CAP - N.O.S. ........................................... :
25 001221 SCREW - 6-32 X l/4 .....................................
26 001052 WASHER - .203 I.D. X l/2 O.D. X .059 ................... 2
* Uot Procurable Separately
40
-.
P
025343 SOLENOID - Etcher, 115 V.A.C. 50/60 HZ. ...................

: 001706 WASHER - Lock, #IO ........................................ :
014515 RING - Plastic, .080 I.D. X .I60 O.D. X .025 .............. 2
: 012415 BRACKET - Solenoid Mount ..................................
041777 SPRING . .312 O.D. X 1.344 O.A.L. X .028 .................. :
:I: 192164 PIN - Solenoid ............................................ 1
12 014215 SCREW - lo-32 X 318 .......................................
192073 SPACER - Mounting Plate ................................... :
:1 012275 PLATE - Mounting, Motor ...................................
15 014808 NUT - lo-32 ............................................... :
012596 COUPLING - Motor Shaft ....................................
:“T 130033 . SCREW - Set, 8-32 X l/4 ................................. :
195330 SLEEVE ..................................................
:; 014158 SCREW - lo-32 X l/2 ....................................... :
20 025348 MOTOR - Etcher, Reducer Assembly, 115 V.A.C. 50/60 HZ. ....
013509 BRUSHES ................................................. :
5: *** MOTOR ASSEMBLY - Master Forwarding ........................
012457 MOTOR - Master Forwarding ............................... :
t: 012146 GEAR - Motor ............................................
25 001573 SCREW - Set, l/4-28 X 5/16 .............................. :
26 012145 BRACKET - Mounting ...................................... 1
001696 SCREW - lo-32 X 7/16 ...................................... 4
5: 192209 SPACER ................................................... 3
4;
1 025260 SHAFT ASSEMBLY - Cam and Gear, (M-9865/69) ................

1 017989 SHAFT ASSEMBLY - Cam and Gear .................... (M-9870) ;
2 001956 PIN - Taper, .194 O.D. X .680 ........................... 4
001987 PIN - Roll, . 167 O.D. x .890 O.A.L. (Use W/O79912 Gear) . .
: 079912 GEAR - (Field Replacement Only) ......................... :
4 *017990 CAM ..................................................... 1
5 *025261 SHAFT ................................................... 1
6 *076727 GEAR .................................................... 1
001094 RING . Retaining External, ,394 I.D. X .044 ...............
: 150085 NUT - l/4-28 .............................................. ;
9 073123 SCREW . Shoulder, l/4-28 .................................. 2
10 014180 SCREW - l/4-28 X 1.000 .................................... 1
073120 BRACKET ASSEMBLY - Bearing, N.O.S. ........................ 1
:: 073094 SCREW - Shoulder, 114-28 ..................................
011079 SCREW - l/4-28 X 1.500 .................................... :
:1 073091 BRACKET ASSEMBLY - Bearing, O.S. .......................... 1
15 007549 ROLLER ASSEMBLY - Distributor ............................. 1
101332 PIN - Spiral, . 103 O.D. X .760 ..........................
:s 001049 RING . Retaining External, .227 I.D. X .027 ............... :
18 021203 WASHER - .254 I.D. X .500 O.D. X .029 ..................... 2
19 054409 SPRING - Compression, 21/64 I.D. X 1.187 O.A.L. ........... 2
20 084422 LEVER ASSEMBLY ............................................ 2
21 084421 BUSHING - Special, .253 I.D. ............................ 1
001047 RING - Retaining, .340 I.D. ............................. 1
;: 072625 SPRING - Tension, 11/32 0.0. X 1.125 O.A.L. X .059 ........
025258 SHAFT AND LEVER ASSEMBLY - Actuating, (M-9865/69) ......... :
It 017633 SHAFT AND LEVER ASSEMBLY - Actuating ............. (M-9870) 1
001098 RING . Retaining External, .339 I.D. X .037 ...............
fZ 014902 PIN - Taper, .llO O.D. X .875 ........................... :
000020 PIN - Taper, ,125 0.0. X .655 ........................... 1
5; 073107 ANCHOR - Spring .........................................
29 077459 SCREW - Shoulder, lo-32 ................................. :
30 193774 TRUCK ................................................... 1
150083 NUT - lo-32 ............................................. 1
;: 016937 SHAFT - Tension ........................................... 1
007591 ROLLER - Ink Ductor, Rubber ...............................
:: 100576 RING - Retaining External, .465 I.D. X .052 ............... :
35 191289 WASHER - ,504 I.D. X .812 0.0. X .062 ..................... 1
CAM GEAR ASSEMBLY .........................................
:P K!; BUSHING - .504 I.D. X ,629 O.D. X .500 .................. :
38 080349 STUD - Shoulder, 3/8-24 ................................... 1
001721 WASHER - .380 I.D. X ,625 O.D. X ,059 .....................
:: 190254 NUT - 318-24 .............................................. :
025198 SOLENOID ASSEMBLY - Ink Feed Control, 120 V.A.C. 50/60 HZ. 1
2: 025347 SOLENOID 120 V.A.C. 50/60 HZ. ........................... 1
43 001729 WASHER - Lock, .145 I.D. X .311 O.D. ....................
44 192206 WASHER - Fiber, .385 I.D. X .625 X ,062 ................. :
45 192204 SPRING - Compression, .437 O.D. X ,406 O.A.L. X .024 ....
190713 PIN - Solenoid .......................................... :
t4 014515 RING - Plastic .......................................... 2
001694 SCREW - 6-32 X 3116 .....................................
:: 001541 SCREW 6-32 X l/4 ........................................ :
49 012815 BRACKET . Mounting ......................................
50 012254 LEVER ASSEMBLY - Lock ................................... :
51 001060 RING - Retaining External, .208 I.D. X .027 ............. 1
52 190149 WASHER .441 1.0. ..........................................
014741 WASHER - Spring, .572 0.0. X .267 1.D X .008 .............. :
:: 017639 STAND-OFF ........................................ 2
55 017640 SPRING - Lockout ................................. 1
56 111053 SCREW - lo-32 x 7116 ............................. 2
44
1 018364 BUSHING ASSEMBLY - N.O.S. ................................ 1

001497 BUSHING - .630 O.A.L. .................................. .
5 111051 SCREW - lo-32 X 5/16 ..................................... . :
4 018368 SHIM - Bushing, N.O.S. .................................... A/R
018360 SEAL - Ink Roller ........................................ . 2
z 018358 ROLLER - Ink, Rubber ..................................... .
018362 BUSHING ASSEMBLY . O.S. .................................. . :
L 014646 BUSHING - 1.255 O.A.L. ................................. . 1
001413 BUSHING - .750 O.A.L. ...................................
;0 072620 SCREW - Shoulder, lo-32 ................................... :
018366 EXTENSION ASSEMBLY - Knob, (M-9865/69) .................... 1
:: 018383 EXTENSION ASSEMBLY - Crank ....................... (M-9870;
000011 PIN - Taper, .122 X 718 ................................. :
:P 018350 METERING BLADE ASSEMBLY ...................................
14 018353 BLADE ASSEMBLY .......................................... :
014808 NUT - lo-32 ............................................. 6
:f 073512 SCREW - Ink Adjustment .................................. 15
17 018357 SPRING - Screw, Tension .................................
017996 TIE BAR - Metering Assembly Adjustment ( Brown ) .......... :
:; 001812 NUT - lo-32 ...............................................
20 001260 SCREW - Adjusting, lo-32 X l-1/4 ......................... :
21 014921 PIN - Roll, .135 O.D. X .890 .............................. 1
No. No. Description Per Assy .
017739 KNOB - Chrome ............................................ 1

196248 SCREW - Dowe1,1/4-28 .....................................
039642 RING - Vinyl, .13,5 I.D. .................................. :
017630 LEVER ASSEMBLY - Operating ...............................
018366 EXTENSION ASSEMBLY - Knob ................................ :
001076 RING - Retaining, .815 I.D. ..............................
017702 CONTROL ASSEMBLY - Ink ................................... :
072052 LOCK - Spring ............................................
011371 HANDLE ................................................... :
018362 HOUSING ASSEMBLY - O.S. .................................. 1
001413 BUSHING - .750 O.A.L. ..................................
014646 BUSHING - 1.255 O.A.L. ................................. :
080630 PAWL .....................................................
001046 RING - Retaining, .283 I.D. .............................. :
080634 SPRING - Torsion, 11/32 I.D. ............................. 1
016574 WASHER - Plain, .315 1.D.X .687 0.D.X .047 ............... 1
076734 LINK - Operating Lever ...................................
072620 SCREW - Shoulder, lo-32 .................................. :
48
P* 0 0 00 mm
Index
No.
Part
No.
192152 SPRING
MODEL 9870 - Figure
Description
- 17164 O.D. x 3-5164 O.A.L.

21A
. . . . . . . . .. . . . . . . .. . . . .
Units
Per Assy
1
.
3
001097 RING - Retaining, .186 I.D. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6
017618 LINK ..................................................... 1
015213 WASHER - .227 I.D. x 318 O.D. ............................ 3
017616 LEVER ASSEMBLY ...........................................
014151 SCREW - lo-32 x l/2 ...................................... :
017623 STAND-OFF ................................................
017611 BRACKET ASSEMBLY ......................................... :
017622 STAND-OFF ................................................
192029 SCREW - Dowel, l/4-28 .................................... :
017613 PLATE ASSEMBLY ........................................... .
017615 LEVER .................................................... . :
014688 WASHER - .510 I.D. x 1.000 O.D. .......................... . 2
001094 RING - Retaining, .394 I.D. .............................. .
014902 PIN - Taper, ,110 O.D. x .720 O.A.L. ..................... . :
018383 EXTENSION ASSEMBLY - Crank ............................... .
017788 CRANK ASSEMBLY - Brown ................................... . :
014215 SCREW - lo-32 x 3/8 ....................................... 1
017630 LEVER ASSEMBLY - Operating ................................
018383 EXTENSION ASSEMBLY - Crank ................................ :
001076 7ING . Retaining, .815 I.D. ............................... 1
017702 CONTROL ASSEMBLY - Ink .................................... 1
072052 _OCK - Spring .............................................
011371 iANDLE .................................................... :
100863 SCREW - lo-32 x l/4 .......................................
018362 iOUSING ASSEMBLY - O.S. ................................... :
001413 BUSHING - .750 O.A.L. ................................... 1
014646 BUSHING . 1.255 O.A.L. .................................. 1
017636 -EVER - Lockout ...........................................
001785 iING - Retaining, .903 I.D. ............................... :
001044 ?IYG - Retaining, .170 I.D. ...............................
017693 'AWL ...................................................... :
001046 lING - Retaining, .283 I.D. ............................... 2
080634 iPRING - Torsion, 11/32 I.D. .............................. 1
196258 ‘IN - Paw1 Deflector ......................................
076734 .INK . Operating Lever .................................... :
072620 iCREW . Shoulder, lo-32 ...................................
196219 :RANK HANDLE KNOB - Brown ................................. :
003042 :LIP . (Not Illustrated) .................................. 1
50
1 041776 SPRING - .343 O.D. X 1.375 O.A.L. X .047 . . . . . . . . . . . . . . . . . .

2 001080 RING - Retaining External, .302 I.D. X .037................ :
075987 LEVER ASSEMBLY - Detent Cam . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1
: 195136 PIVOT - Lever . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
073894 SLIDE - Form Roller Lever . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . :
65 014207 SCREW - Set, l/4-28 X 518 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
073482 COUPLING - Waver Roller .. . . . . . . . . . . . . . . . . . . . . .. . . . . .. .. . . . :
: *** ROLLER AND SHAFT ASSEMBLY - Waver . . . . . . . . . . . . . . . . . . . . . . . . . 1
9 014157 SCREW - l/4-28 X 1.250 . . . . . . . . . . . . . . . . . . . . . . . . . . . ...*... 3
007557 SHAFT ASSEMBLY . . . . . . . .. . . . . . . . . . . . . . . . . . . . . . . . . . . . .. . . . . 1
:: 073710 GEAR . . . . . . . . . . . . ..*........... (Field Replacement Only)
12 001976 PIN - Roll, .135 0.0. X .827 ..(Field Replacement Only) :
014910 PIN - Taper, .llO O.D. X 7/8 . . . . . ..a..................
:3 079905 GEAR . . . . . . . . . . . . . . . . . . . . . . . . . . . (Field Replacement Only) :
14 014921 PIN - Roll, .135 O.D. X .890 ..(Field Replacement Only) 1
014910 PIN - Taper, .llO 0.0. X 7/8 . . . . . . . . . . . . . . . . . . . . . . . . . .
:: 007559 ROLLER ASSEMBLY - Waver . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . :
080433 CAP . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1
:; 080473 CAP . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
18 111055 SCREW - lo-32 X 9/16 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . :
075931 BUSHING - Flanged . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . ...*
:: 001497 BUSHING - .504 I.D. X .629 0.0. X .625 . . . . . . . . . . . . . . . . . . f
21 014248 NUT - lo-32 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . ..*.............. 4
075991 BRACKET - Spring . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .. . . . .
;; 190254 NUT - 318-24 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .. . . . :
,385 I.D. X .875 O.D. X .059 . . . . . . . . . . . . . . . . . . . . .
f% !%3:: !%~ER . . -
. . . . . . . . . . . . . . . . . . . . ..*............................. :
26 076218 GEAR . . . . . . . . . . . ..*........................................ 1
27 001797 WASHER - .515 I.D. X .812 O.D. X .059 . ....... ..... ........ 1
28 001048 RING - Retaining External, .463 I.D. X .037 ... ... ........ . 1
*** Not Saleable As An Assembly
52
Part MODEL 9865/9869 - Figure 23 Units
No. Description Per Assy.
007599 SHAFT ASSEMBLY - Form Roller .............................. 2

001978 PIN . Roll, .135 X .765 ................................. 1
001980 PIN - Roll, .135 X .640 .................................
017735 KNOB - Form Roller ........................................ :
039642 RING . Vinyl, .135 1.D ..................................... 3
196246 SCREW . lo-32 X 9/16 .......................................
014819 NUT - 5116-24 ............................................. $
076481 SCREW - Eccentric Adjusting, 5/16-24 ......................
072272 LEVER - Lock .............................................. t
014912 PIN . Roll, . 167 O.D. X .515 ............................ 4
072271 STUD . Locking, lo-32 ..................................... 4
073338 SPRING - Compression, .572 O.D. X 1.265 O.A.L. X .059 ..... 2
076124 SPRING - Compression, .537 O.D. X 1.343 O.A.L. X .063 ......
014108 SCREW . Set, lo-32 X 318 .................................. ;
073327 SLEEVE . Form Roller ...................................... 2
007567 ROLLER ASSEMBLY - Upper Form 2" Dia.,Rubber ...............
073316 BEARING - Ball, .437 I.D. X .906 O.D. X ,312 ............ :
007567 ROLLER ASSEMBLY - Lower Form 2" Dia.,Rubber ...............
001577 SCREW . 8/32 X 7116 ....................................... :
073098 RETAINER - Stop Plate ..................................... 4
073097 PLATE . stop .............................................. 2
073446 LEVER - Upper Form Roller, 2" Dia., N.O.S. ................
073444 LEVER . Upper Form Roller, 2" Dia., O.S. .................. :
073447 LEVER - Lower Form Roller, 2" Dia., N.O.S. ................ 1
073448 LEVER . Lower Form Roller, 2" Dia., O.S. ..................
193917 SCREW . Shoulder, l/4-28 .................................. :
0085 NUT - l/4-28 ..............................................
3336 ANCHOR . Spring ........................................... f
6248 SCREW - lo-32 X 314 ....................................... 1
5270 KNOB . Night Latch ........................................
5264 SHAFT ASSEMBLY - Form Roller Separator .................... :
1333 PIN . Spiral, .125 O.D. X .937 .......................... 1
0 0554 PIN - Spiral, .125 O.D. X .750 ..........................
114507 RING . Retaining External, .095 I.D. X .019 ............... 2’
9 0382 PIN - Special .............................................
0383 CLIP - Spring ............................................. ;
2763 TUBE . 9/16 I.D. X 13-15/16 O.A.L. ........................
0969 RING . Retaining, .447 I.D. ............................... :
9 2798 WASHER . .507 I.D. X .875 O.D. X ,060 .....................
7 6386 GEAR . Idler .............................................. :
i 1068 SCREW - l/4-28 X 5116 ..................................... 4
1203 WASHER - .254 I.D. X .500 O.D. X .029 .....................
: 3029 BUSHING - Separator Shaft ................................. 2”
54
014819 NUT - 5116-24 ............................................

: 076481 SCREW . Eccentric Adjusting, 5/16-24 ..................... :
072271 STUD - Locking, lo-32 .................................... . 2
i 072272 LEVER - Locking, Stud N.O.S. .............................
014912 PIN - Roll, .167 O.D. x .515 O.A.L. .................... . :
2 073445 FORM ROLL LEVER - N.O.S. ................................. .
014108 SCREW - Set, lo-32 x 3/8 ................................. . :
; 193917 SCREW - Dowel, l/4-28 x 5116 ..............................
150085 NUT - l/4-28 ............................................. . ;
Yo 195930
073327
SPRING
SLEEVE
- Compression,
- Form Roller
.510 I.D. x l-1/4 O.A.L. (White) ... . 2
..................................... .
::
13
007565
073316
ROLLER ASSEMBLY
BEARING
- Lower Form (2.4 Diameter) ...............
- .437 I.D. x .906 0.0. .........................
:
2
14 001577 SCREW - 8-32 x 7116 .......................................
073098 - Stop Plate ..................................... 5
:z 073097 "pzv'" - stop ..............................................
073443 FORM ROLL LEVER - O.S. .................................... :
:2: 017626 LEVER . Locking, Stud O.S. ................................
19 100741 RING . Retaining, .146 I.D. ............................... :
20 192152 SPRING - 17164 0.0 x 3-5164 O.A.L. ........................ 1
21 007599 SHAFT ASSEMBLY . Form Roller ..............................
22 001978 PIN - Roll, .135 O.D. x .765 O.A.L. ..................... :
23 001980 PIN - Roll, .135 0.0. x .640 O.A.L. .....................
24 017735 KNOB ...................................................... :
25 039642 RING - Vinyl, .135 I.D. ................................... 1
196246 SCREW . Dowel, l/4-28 .....................................
fY 072278
072277
ANCHOR - Spring, N.O.S. ................................... :
ANCHOR . Spring, O.S. ..................................... 1
101033 SCREW . Set 8-32 x l/2 .................................... 1
-56
1 017619 SHAFT ASSEMBLY - Form Roller Separator .................... 1

071594 COLLAR - Eccentric ......................................
: 014372 SCREW - Set, lo-32 x l/4 ................................ :
4 000009 PIN - Taper, .750 O.A.L. ................................
5 001978 PIN - Roll, .135 O.D. x .765 O.A.L. ..................... :
6 *017620 LEVER - Separating ...................................... 1
*071649 CAM - O.S. Form Roller Separator ........................ 1
; *007554 SHAFT - Form Roller Separator ........................... 1
9 *071648 CAM - N.O.S. Form Roller Separator ......................
10 *055535 COLLAR - Separator Shaft ................................ :
11 192763 T-UBE - ,572 I.D. x .622 O.D. x 14.077 ..................... 1
12 014507 RING - Retaining, .097 I.D. ............................... 2
190382 PIN - Spring Clip .........................................
:4” 190383 CLIP . Spring ............................................. 2’
15 192798 WASHER - .507 I.D. ........................................ 1
16 100969 RING - Retaining, .447 1.0. ............................... 1
076386 GEAR - Idler .............................................. 1
:; 001427 BUSHING . .503 I.D. x .628 O.D. x .880 O.A.L. ........... 1
19 073029 BEARING HOUSING ...........................................
20 111068 SCREW . l/4-28 x 5/16 ..................................... :
21 021203 WASHER . .255 I.D. x .500 O.D. ............................ 4
-58
Part MODEL 9870 - Figure 23C Units
Index
No.
1 022736 ROLLER - Form, 3rd ........................................ 1

2 073316 BEARING - .906 O.D. x .437 I.D. .........................
4 022739 SHAFT - Form Roller ....................................... :
190149 WASHER - .443 I.D. x 11/16 O.D. x ,030 .................... 1
6” 001075 RING - Retaining, .397 I.D. x .037 ........................ 1
9 022743 PLATE - Mounting, N.0.S ....................................
11 150085 NUT - I/4-28 .............................................. :
12 022740 NUTPLATE ..................................................
13 191734 SCREW - Dowel, .250 O.A.L. ................................ z
14 083594 ECCENTRIC .................................................
15 111074 SCREW - I/4-28 x 314 ...................................... 2’
022728 PLATE ASSEMBLY - Adjusting, N.O.S. ........................
:5 022731 BRACKET ASSEMBLY - Support, N.O.S. ........................ :
19 021457 SPRING - Tension, .390 O.D. x 1.75 O.A.L. x .054 .......... 2
022729 BRACKET ASSEMBLY - Support, O.S. ..........................
EY 022744 SCREW Shoulder ............................................ :
22 196787 SPRING - Compression, .480 O.D. x l.O.A.L. x .059 ......... 2
23 191733 SCREW . Dowel, 1.171 O.A.L. ............................... 4
24 196778 COLLAR .................................................... 1
001207 SCREW . Set, 8-32 ......................................... 1
E 014810 NUT - 318-24 .............................................. 2
191736 SPACER - .317 I.D. x .750 O.D. x .599 ..................... 1
5: 195387 SPACER - .317 I.D. x .500 O.D. x .599 ..................... 1
022743 PLATE - Mounting, O.S. .................................... 1
5; 022727 PLATE ASSEMBLY - Adjusting, O.S. ..........................
31 196475 NUT - Special ............................................. 5
080694 PLUG ASSEMBLY . Oscillating Roller ........................ 1
:P 001497 BUSHING ................................................. 1
34 007577 ROLLER - Oscillating, Nylon ............................... 1
007580 ROD - Tie .................................................
:6” 080695 PLUG AND CAM ASSEMBLY ..................................... :
37 080699 BALL ...................................................... 1
38 080263 CAP .......................................................
39 014390 SCREW - Set, l/4-28 x l/4 ................................. :
080698 GUARD ..................................................... 1
:: 014523 RING - Retaining: 2.346 I.D. x 2.600 O.D. x .081 ..........
022734 SHAFT - Oscillating Roller, 3rd Form ...................... :
t5 001812 NUT - lo-32 ............................................... 2
44 016558 WASHER - Plain, .203 I.D. x 9/16 O.D. x .058 .............. 2
196769 STUD - Adjust ............................................. 2
is5 022781 STUD - Eccentric .......................................... 2
001766 WASHER - Plain, .325 I.D. x l/2 O.D. x ,030 ...............
t;: 100969 RING . Crescent, l/2" Shaft ............................... :
60
P8i!Fk&)
00 mm 0 0

001060 RING - Retaining, .208 I.D. X .027 .........................

021203 WASHER - Plain, l/4 I.D. X l/2 O.D. X .029 ................ :
014805 NUT - 7116-20 .............................................
043097 WASHER - Plain, 7/16 I.D. X 314 O.D. X .059 ............... :
195137 STUD . Bushing ............................................ 1
193605 SPACER - Dowel Screw, l-3/32” ............................. 1
195650 SPACER - Dowel Screw, 19/32" ..............................
001684 SCREW - l/4-28 X 7116 ..................................... :
250203 CLAMP - Nylon, l/4" ....................................... 2
250204 CLAMP - Nylon, 5116" ......................................
250205 CLAMP - Nylon, 3/16" ....................................... :
001588 SCREW . lo/32 X I/4 .......................................
025125 SOLENOID PLATE ASSEMBLY . Form Roller ..................... :
014515 RING - Vinyl, .080 I.D. .................................
190713 PIN - Solenoid Link ..................................... :
253578 SOLENOID - 115 V. 50/60 Hz. .............................
025127 LINK ASSEMBLY ........................................... :
111033 SCREW - 8-32 X 5/16 ..................................... 2
025126 BRACKET - Solenoid Mtg. .................................
111051 SCREW - IO/32 X 5116 .................................... :
195000 STUD - Switch Link ...................................... 1
150085 NUT - l/4-28 ............................................ 1
025129 LINK ASSEMBLY - Night Latch Switch ...................... 1
251086 SWITCH - 10 A. 125/250 VAC. ............................. 1
111006 SCREW - 4-40 X 9116 ..................................... 2
006917 INSULATION - Switch ..................................... 1
025132 BRACKET - Switch Mtg. ...................................
190555 NUTPLATE - 4-40 ......................................... :
101151 SCREW - 6-32 X 5/16 ..................................... 1
084353 PLATE . Solenoid and Switch Mounting ....................
001047 RING - Retaining, .340 I.D. ............................... :
195141 WASHER 1 ;;ap;;g, .402 I.D. X .557 O.D. X .lOO ............. 1
014703 WASHER .584 I.D. X .562 O.D. .....................
025171 SLIDE ASSEMBLY'- Power .................................... :
025273 LINK ASSEMBLY - Power ..................................... 1
193871 SPRING - Tension, l/P” O.D. X 11/16” O.A.L. ............... 1
025375 LEVER ASSEMBLY . Control ..................................
193795 dASHER - Trust, .320 I.D. X .625 O.D. X .030 .............. :
001095 ZING . Retaining, ,245 I.D. ................. .: ............
064673 SPRING - Tension, .375 O.D. X 1.375 O.A.L. ... ..‘........... :
62
Part MODEL 9865/9869 - Figure 25 Units
Index
No.
025103 MASTER FEED TABLE ASSEMBLY - M-9865/69 .................... 1

: 022783 MASTER FEED TABLE ASSEMBLY - (Not Illustrated) ... (M-9870: 1
001080 RING . Retaining External, .302 I.D. X .037 ............. 1
P
4
014727
001772
WASHER - .750
WASHER - Spring,
O.D. X .382 I.D.
,760 O.D. X ,382 I.D. X .151 ...........
X ,029 ................... 2
1
s 012450
014380
SLIDE EXTENSION - Feed Table
NUT . Wing lo-32 ........................................
............................ 1
4
i
9
014760
011222
011224
WASHER - .750 O.D. X .220 I.D.
GUIDE - O.S.
GUIDE - N.O.S.
............................................
..........................................
X .059 ................... 4
:
10 025104 FEED TABLE .............................................. 1
014151 SCREW - lo-32 X l/2 .....................................
:: 101001 SCREW - lo-32 X 3/8 ..................................... :
014808 NUT . lo-32 ............................................. 8
:i 011199 BRACE - Feed Table ...................................... 2
025106 BAR SUPPORT . Feed Table ................................ 1
:i 014112 SCREW . l/4-28 X 7/B .................................... 4
17 012661 SPRING - Paper Tension ..................................
001289 SCREW - 8-32 X l/4 ...................................... 5
:: 080241 SPRING - Compression, .517 O.D. X 1.265 O.A.L. X .066 ..... 1
20 012449 KNOB - Separating Adjustment .............................. 1
21 025373 HARNESS ................................................... 1
250077 TIE - Cable ............................................. 2
f5 250062 CONNECTOR ............................................... 8
24 ‘IX* BOX - Switcn Assembly ..................................... 1
25 001090 RING - Retaining, Bowed, .463 I.D. ......................
26 025243 TUBE .................................................... :
27 001048 RING - Retaining, .463 I.D. ............................. 1
28 001588 SCREW . lo-32 X l/4 ..................................... 2
013413 BOX . Switch ............................................ 1
5: 007932 SHEILD . Reed Switch ....................................
31 001812 NUT - lo-32 ............................................. :
028797 ARM - Switch ............................................ 1
z 001782 RING - Retaining, .115 I.D. ............................. 1
34 181019 RING . Retaining,Bowed, .146 I.D. .......................
195499 STUD .................................................... :
:; 190555 NUTPLATE ................................................ 1
37 251710 SWITCH . 125 V., 3 Amp. ................................. 2
190557 INSULATOR ...............................................
z: 111006 SCREW . 4-40 X 9J16 .....................................
*** Not Saleable As An Assembly
64
1 012246 SWITCH AND MOUNTING BRACKET ASSEMBLY .....................

2 012654 BRACKET - Fixed Switch ................................. :
012655 BRACKET - Pivot Switch ................................. 1
: 192199 SCREW - Thumb .......................................... 1
001052 WASHER - .203 I.D. X.500 O.D. X .059 ................... 5
2 190135 SPRING - Compression, ,350 O.D. X 1.000 O.A.L. X .045 . .
7 014215 SCREW - lo-32 X 3/B .................................... :
a 014770 WASHER . Spring, .594 I.D. X .a75 O.D. X ,010 .......... 3
9 250071 SWITCH - Micro, 125/250 V.A.C. ......................... 1
10 250300 ACTUATOR - Micro Switch ................................ 1
084279 INSULATOR - Micro Switch ............................... 1
:: 012243 INSULATOR - Micro Switch ...............................
13 100490 SCREW - 2-56 X l/2 ..................................... :
250203 CLAMP - Cable,Nylon, l/4" ................................
:z 001586 SCREW - B-32 X 5116 ...................................... :
16 052218 SPRING - Tension, .250 O.D. X l-5/16 O.A.L. X .028 ........ 1
66
1 014807 NUT - l/4-28 ............................................. 3

2 195161 SCREW - l/4-28 X 518 ..................................... 3
011019 BRACKET ASSEMBLY - N.O.S. ................................ 1
4” 195160 SCREW - l/4-28 X 7/16 .................................... 2
025120 BRACKET ASSEMBLY - O.S. .................................. 1
5 001586 SCREW - 8-32 X 5116 ...................................... 2
025197 MASTER FORWARDING SOLENOID ASSEMBLY - 115 Vat. 50/60 Hz. .
f3 025345 SOLENOID - 115 Vac,50/60 Hz. ........................... :
9 012155 BRACKET - Master Forwarding Solenoid ...................
101773 SCREW - 6-32 X 318 ..................................... :
:: 014515 RING - Plastic .080 I.D. X .160 O.D. X .025 ............ 2
191463 PIN - Solenoid .........................................
:5 192991 SPRING - Tension, ,375 O.D. X 1.734 O.A.L. X .043 ...... :
14 001729 WASHER - #6 ............................................ 3
16 250098 CLAMP - Cable ............................................ 1
17 101612 SCREW - l/4-28 X 7116 .................................... 1
L 68
No. No. Description Per Assy,
025075 MASTER FORWARDING UNIT ASSEMBLY ...........................

: 101007 SCREW - Set, lo-32 X 3116 ...............................
3 012659 FEED ROLL - Serrated .................................... ;
4 012660 HUB - Serrated Feed Roll ................................ 2
012444 FEED ROLL ASSEMBLY ......................................
2 * FEED ROLL ............................................. :
7 * HUB - Feed Roll .......................................
063206 COLLAR - Feed Roll Shaft ................................ :
: 042150 PIN - Roll, .103 O.D. X .765 ............................
10 012147 GEAR ASSEMBLY - Feed Roll ............................... :
11 * GEAR - Feed Roll ...................................... 1
12 001784 RING - Retaining External, .566 I.D. X ,037 ........... 1
13 101020 CLUTCH - Gear Assembly ................................ 1
14 SLEEVE - Clutch .......................................
15 :25097 SHAFT - Feed Roll ....................................... :
16 025094 FEELER SHAFT ASSEMBLY ...................................
17 * FEELER SHAFT .......................................... :
18 * LEVER - Feeler Shaft ..................................
19 100880 PIN - Roll, .086 O.D. X .515 .......................... :
20 192182 SPRING - Tension, .250 0.0. X 1.000 O.A.L. X .016 .......
21 193762 BUSHING - .157 I.D. X .220 O.D. X .500 .................. :
23 011273 BUSHING - Feeler Shaft and Stop ......................... 2
24 192158 SPACER - Feeler Shaft ...................................
25 025092 STOP ASSEMBLY ........................................... :
072625 SPRING - Tension, .343 O.D. 1.125 O.A.L. X ,039 ......... 1
5; 193443 STUD - Spring ...........................................
28 011253 LATCH ASSEMBLY .......................................... :
29 031307 SPRING - Tension, .222 0.0. X .656 O.A.L. X .020 ........
30 195348 STUD - Spring ........................................... :
31 014465 RING - Retaining External, .301 I.D. X.045 .............. 2
32 011262 BRACKET - Roller ........................................
33 032868 PIN - Roll, . 135 O.D. X .452 O.A.L. ................... :
001429 BUSHING - .315 I.D. X .439 O.D. .625 .................. 2
;t 191782 SPACER - .318 I.D. X .562 O.D. X .150 ................... 1
36 025088 ROLLER ASSEMBLY ......................................... 1
37 192065 STUD - Pivot Roll Lever ................................. 2
38 001094 RING - Retaining External, .394 I.D. X .044 .............
014350 SCREW - lo-32 X 5/16 .................................... :
3: 021563 WASHER - .194 I.D. X .375 O.D. X .029 ................... 4
41 011132 LEVER - Upper Forwarding Roll, R.H. .....................
011133 LEVER - Upper Forwarding Roll, L.H ....................... :
t: 025090 SUPPORT - Upper Forwarding Roll ......................... 1
44 195331 SPRING - Tension, 7/16 O.D. X l-1/16 O.A.L. X .055 ......
101554 SCREW - Set, lo-32 X 518 ................................ ;
t; 014215 SCREW - lo-32 X 318 ..................................... 4
47 025082 CHUTE ................................................... 1
48 001575 SCREW - lo-32 X 5/16 .................................... 2
49 014151 SCREW - IO-32 X I/2 ..................................... 4
025079 TABLE -Machine ..........................................
;: 025084 ROLLER AND GEAR ASSEMBLY ................................ :
52 * GEPR .................................................. 1
53 149344 PIN - Taper, .950 O.D. X ,687 ......................... 1
54 012537 BUSHING - Roller Shaft .................................. 1
55 005311 WASHER - .445 I.D. X .620 O.D. X .047 ................... 1
100884 RING - Retaining External, .415 I.D. X .053 .............
Zf 192157 STUD - Roller Shaft Bushing ............................. :
-70
Pa 0 0 00 mm

0 025075 MASTER FORWARDING UNIT ASSEMBLY ..........................

1 025098 FRAME - Etcher, 0.S ..................................... :
025100 FRAME - Etcher, N.O.S. .................................
: 192073 BUSHING - .208 I.D. X .437 O.D. X .280 ................. .:
7 012275 PLATE ..................................................
8 014808 NUT - lo-32 ............................................ . :
9 014136 SCREW - lo-32 X 7116 ................................... 6
012597 GEAR - Pinion Drive .................................... 1
:: 012599 HUB AND BUSHING ........................................ . 1
BUSHING . .253 I.D. X .377 O.D. X .750 ............... .
:5 ;01106 SCREW . lo-32 X 5116 ................................... . :
021203 WASHER - ,253 I.D. X .500 O.D. Y .059 .................. . 1
:: 001060 RING - Retaining External, .208 I.D. X .027 ............ 1
16 025101 GUIDE - Rail ............................................ . 2
17 100122 SCREW - lo-32 X 7116 ................................... .
001536 SCREW . lo-32 X 318 ..................................... . ;
:: 014110 SCREW - l/4-28 X 1.000 ................................. . 2
20 011154 BLOCK MOUNTING ASSEMBLY - O.S. ......................... .
21 012178 BLOCK MOUNTING ASSEMBLY . N.O.S. ....................... . :
22 001430 BUSHING . .441 I.D. X .565 O.D. X .500 ................ 1
001404 BUSHING - .379 I.D. X .504 O.D. X .500 ................
2’: 012228 BUSHING - .379 I.D. X .500 O.D. X .309 ................ ;
25 014618 BUSHING - .629 I.D. X .752 O.D. X .500 ............... . 2
012151 HUB ................................................... 1
f ! 195348
025096
STUD - Spring ..........................................
TIE BAR .................................................
.
:
:; 150085 NUT - l/4-28 ............................................ 2
30 012150 LATCH ASSEMBLY ......................................... . 1
31 001975 PIN - Roll, .103 O.D. X .500 .......................... 1
32 * LEVER .................................................
* LEVER ................................................ . :
:3 012170 GEAR - Master Forwarding, 22 Teeth ...................... 1
012168 GEAR - Master Forwarding, 24 Teeth ...................... 1
;z 001412 BUSHING . .441 I.D. X .565 O.D. X .375 ................
37 192055 STUD - Master Forwarding Gear ........................... ;
190149 WASHER . .443 I.D. X .687 O.D. X .029 ................... 2
z: 001098 RING - Retaining External, .339 I.D. X .037 ............. 2
40 077822 STUD - Spring ........................................... 1
41 100367 SCREW - Set, l/4-28 X l/2 ............................... 2
42 014810 NUT . 318-24 .............................................. 2
43 100860 SCREW - 3/8-24 X 1.00 ..................................... 2
001721 WASHER - .380 I.D. X .625 O.D. X .059 ..................... 2
193609 SCREW . Shoulder .......................................... 2
Not Procurable Separate lY
7;
0 025075 MASTER FORWARDING UNIT ASSEMBLY . . . . ..*.................... 1

1 025086 TIE BAR ................................................. 1
100815 SCREW - I/4-28 X 1.125 .................................. 3
5 014234 SCREW - l/4-28 X 1.000 ..................................
4 001649 SCREW - lo-32 X l/2 ..................................... :
5 011256 BRACKET ASSEMBLY ........................................
6 011274 BUMPER .................................................. :
7 195366 SCREW - Bumper .......................................... 1
8 001818 NUT - l/4-28 ............................................ 1
9 BRACKET - Mounting Separator Roll .......................
10 8:z SCREW . l/4-28 X 518 ...................................... :
12 192168 PIN . Hinge Separator Roll Lever ........................ 1
13 *** SEPARATOR ROLLER ASSEMBLY ............................... 1
14 012443 ROLLER . Separator .................................... 1
15 063117 BUSHING - Roller ...................................... 1
012440 LEVER - Separator Roll .................................. 1
:; 192877 STUD - Separator Roll ................................... 1
025076 OPERATING SHAFT AND LEVER ASSEMBLY ......................
:; * LEVER ASSEMBLY . R.H. ................................. :
20 195175 TRUCK ............................................... 2
21 001097 RING - Retaining External, .186 I.D. X .027 ......... 2
22 012687 TRUCK ............................................... 1
23 192258 WASHER - .381 I.D. X .562 O.D. X .OlO ...............
24 001047 RING - Retaining External, .340 1.0. X .027 ......... :
* LEVER AND SHAFT ASSEMBLY - L.H. ....................... 1
;z 191252 PIN - Taper, .176 0.0. X J/8 ..........................
27 011252 BRACKET ASSEMBLY ...................................... :
28 195351 STUD - Follower ....................................... 1
29 011259 TRUCK ................................................. 1
001052 WASHER . .203 I.D. X .500 O.D. X .059 ................. 1
if 101051 NUT . lo-32 ........................................... 1
32 014245 SCREW . Set, lo-32 X J/8 ................................ 1
195404 STUD . Spring ........................................... 1
Z% 041774 SPRING . Tension, .250 0.0. X .781 O.A.L. X .023 ........ 1
35 192181 SPRING - Tension, .250 0.0. X .859 O.A.L. X ,024 ........ 1
36 012235 COLLAR ..................................................
37 001650 SCREW - Set, lo-32 X 3/16 ............................... :
38 018062 WASHER - Plain, 21/64 I.D. X 5/8 O.D. X .059 ............ 1

74
Index
No.
Part
No.
*** CYLINDER ASSEMBLY

MODEL 9865/9869
- Master
- Figure
Description
31
................................
Units
Per Assy
1
.I
077939 SPRING - Tension, .351 O.D. X 2.796 O.A.L. X .035 .......
196427 SPRING - Tension, .489 O.D. X 1.750 O.A.L. X .065 ....... 5
100958 SCREW - Nylok, a-32 x .375 .............................. 11
025034 FINGER - Gripper ........................................
025468 FINGER - Stripper ....................................... :
195005 ANCHOR - Spring, i/4-28 .................................
191498 SCREW - Shoulder, l/4-28 ................................ 5
025032 SHAFT ASSEMBLY - Gripper ................................
100554 PIN - Spiral, .136 O.D. X .760 ........................ :
* ARM ................................................... 1
* SHAFT .................................................
084225 BRACKET - Shaft ......................................... :
191497 BUSHING ...............................................
073326 SPRING - Tension, .312 O.D. X .781 O.A.L. X .031 ........ :
001095 RING - Retaining External, .245 I.D. X .027 ............. 1
014248 NUT . lo-32 ............................................. 2
025047 ARM - Tail Clamp, N.O.S. ................................
025046 ARM - Tail Clamp, O.S. .................................. :
195006 SCREW - Tension, l/4-28 ..................................
192997 SPRING - Conical Compression ............................ f
025044 PLATE ASSEMBLY - Pin Bar ................................
100246 SCREW - l/4-20 X 1.000 .................................. :
100813 SCREW - Shoulder, l/4-20 ................................ 2
.
025036 ANVIL ...................................................
001776 RING - Retaining External, .146 I.D. X .027 ............. :
101757 SCREW - Set, l/4-28 X .625 .............................. ‘1
025038 LEVER ASSEMBLY - Arm .................................... 1
001049 RING - Retaining External, .227 I.D. X .027 ...........
193259 WASHER - .257 I.D. X .437 O.D. X .OlO ................. :
012716 TRUCK .................................................
014250 SCREW - a-32 x 3/a ...................................... ;
012827 HOUSING .................................................
084117 SCREW - Spring Stud ..................................... :
076122 ANCHOR - Spring ......................................... 2
014111 SCREW - 114-28 x 578 .................................... 5
025043 GEAR . Ducting Cam, O.S. ................................
014516 RING - Retaining Internal, 2.742 O.D. X .OBl ............ :
080814 BEARING - Ball, 1.181 I.D. X 2.440 O.D. X .629 .......... 2
080910 GEAR - Cam Ducting, N.O.S. .............................. 1
053184 SCREW - Dowel, l/4-28 ................................... 1
025049 GEAR - Cylinder .........................................
001991 ANCHOR - Spring ......................................... :
025030 CYLINDER - Master ....................................... 1

Clean-up Mats (Supply 4-1410 )
76
1 009774 TAIL CLAMP ASSEMBLY . . . . .. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

2 190137 SPRING - 13/32 O.D. x 2-5/8 O.A.L. . .. . . . . . . . . . . . . . . . . . . . . . 2
192997 SPRING - Conical, .270 I.D. x . 530 I.D. x 19/32 O.A.L. ....
7 192919 SCREW - l/4-28 x 718 . . . . . . . . . . . . . . . . . . . . . . . ..*...........* z
014215 SCREW - lo-32 x 3/8 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4
2 009788 BRACKET - Clamp, N.O.S. . . . . . . . . . . . . . ..*..*................
009780 BRACKET - Clamp, Positioning . . . . . . . . . . ..*................. :
: 001106 SCREW - lo-32 x 5/16 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2
9 018602 BAR . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . ..*....................
001060 RING - Retaining, .208 I.D. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . :
:; 194695 PIN - Spring Anchor ....................................... 4
196425 SCREW - Pivot . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
:P 018595 BRACKET - Clamp, O.S. . . . . . . . . . . . . . ..*.........*........... :
14 018594 KNOB - Lateral Adjustment . . . . . . . . . . . . . . . . . . . . . . . . . . . . .. . . . 1
190329 SPRING - Compression, 11/32 I.D. x 3/8 O.A.L. .............
:: 018596 BRACKET - Lateral Adjustment . . . . . . . . . . . . . . . .. . . . . . . . . . . . . . :
014250 SCREW - Cap, 8-32 x 3/8 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2
:: 014504 RING - Retaining, .146 I.D. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1
19 018593 ECCENTRIC - Swivel Adjustment . . . . . .. . . . . . . . . . . . . . . . . . . . . . .
20 195837 WASHER - 17/64 I.D. x 3/4 O.D. x .125 . . . . . . . . . . . . . . . . . . . . . :
077836 SPRING - Compression, 25164 O.D. x 23132 O.A.L. ...........
5: 018599 KNOB ASSEMBLY - Swivel Adjustment ......................... :
001207 SCREW - Set, 8-32 x 3/16 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1
;: 021203 WASHER - .255 I.D. x ,500 O.D. . . . . . . . . . . . . . . . . . . . . . . . . . . . .
26 001725 WASHER - Spring, 17/64 I.D. x 7/16 O.D. . . . . . . . . . . . . . . . . . . . :
27 009777 LEVER - Lockout ........................................... 1
001095 RING - Retaining, .245 I.D. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
z 009796 LEVER . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . ' .* :
014215 SCREW - Cap, lo-32 x 318 . . . . . . . . . . . . . . . . . . . . . . . . . . ...*....
z 001588 SCREW - lo-32 x l/4 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1
080238 SPRING - 17/64 I.D. x 2.000 O.A.L. . . . . . . . . . . . . ..*......... 2
:P 018623 CLAMP ASSEMBLY - Universal . . . . . . . . . . . . . . . . . . . . . . . . . . .. . . . .
009757 HINGE ASSEMBLY ............................................ :
:z 018604 PLATE - Clamp . . . . . . . . . . . . . . . . . . . . . . . ..*...................
36 018603 BAR - Radial Adjustment ................................... :
37 009751 MASTER CYLINDER . . . . . . . . .. . . . . . . . . .. . . . . . . . . . . . . . . . . . . . . . . .
38 018624 HEAD CLAMP ASSEMBLY . . . . . . . . . . . . . . .. . . . . . .. . . . . . . . . . . .. . . . . :
78
1 014111 SCREW - l/4-28 x 5/8 ......................................

100653 SCREW - l/4-28 x 314 ......................................
: 014516 7ING - Retaining, 2.742 O.D. ..............................
5 080814 3EARING ...................................................
6 080820 :OLLAR - Cylinder Locking .................................
7 014206 SCREW - Set, l/4-28 x 318 .................................
8 009794 :OLLAR ASSEMBLY ...........................................
9 100201 SCREW - l/4-28 x 718 ....................................
10 100167 SCREW - Set. l/4-28 x 518 ...............................
009751 'lASTER CYLINDER ...........................................
:: 009791 ;EAR - Master Cylinder ....................................
13 080910 :EAR - Ducting Gear .......................................
80
No. No. Description Per Ass)
1 100141 SCREW - l/4-28 X l/2 ...................................... 6

080972 SPACER - Master Cylinder,Shaft Bearing ....................
3’ 082057 BEARING ASSEMBLY .......................................... 2”
4 *193603 BUSHING - 1.125 I.D. X 1.315 O.D. X .625 ................ 2
014206 SCREW - Set, l/4-28 X 3/8 ................................. 2
z 080820 COLLAR - Shaft ............................................
7 014517 RING - Retaining External, 1.039 I.D. X .052 ............... :
8 007628 SHAFT - Master Cylinder ...................................
001094 RING - Retaining External, ,394 I.D. X .044 ............... :
YO 072394 PIVOT - Support Link ...................................... 2
080911 LINK SUPPORT - Master Cylinder ............................
:: 100857 SCREW - 318-24 X l-3/8 (M-9865/69) ........................ f
014173 SCREW - 5116-18 X l-112 ................................... 2
:43 001840 NUT - 5/16-18 .............................................
15 001821 NUT - l/4-28 .............................................. :
014172 BOLT - l/4-28 X 3-314 ..................................... 2
:; 072416 GUIDE - Support arm Spring ................................
18 194808 SPRING - Compression, .794 O.D. X 2.937 O.A.L. X .090 ..... :
19 072399 BLOCK ASM. - Master Cyl. Support Arm, O.S. (M-9865/69) ..... 1
20 012277 BLOCK ASM. - Master Cyl. Support Arm N.O.S. (M-9865/69) ....
001986 PIN - Roll, . 199 O.D. X .952 N.O.S. .................... :
;: 014972 PIN - Spirol, .202 O.D. X ,937 O.S. ....................
100176 PIN - Roll, ,199 O.D. X .577 ............................ 1’
55 080716 SUPPORT ARM - Master Cylinder .............................
24 080715 SCREW . Support Arm Stud, 5/16-24 ......................... f
@@J?_l7 STUD - Support Arm ........................................ 2
I: D%$4 ?90 SCREW - Set, lo-32 X l/4 .................................. 2
080‘956 COLLAR - .504 I.D. X 15/16 O.D. X 13/32 .................. 1
El 080447 PIN - Separator .................................. M-9870) 2
29 014121 SCREW - 3/8-24 x l-1/4 ........................... I M-9870) 2
30 010372 BLOCK - Support Arm, W/Gap Control ............... (M-9870) 2
100131 PIN - Roll, .199 O.D. x 1.230 O.A.L. ........... (M-9870) 1
:: 078346 LEVER - stop, ....................................
33 150089 NUT . 318-24 ..................................... :
8
P@i!Jk&$
0 00 mm 0

1 196246 SCREW - Special, lo-32 x 314 .............................. 1

039642 RING . Vinyl, .135 I.D. x .075 ............................ 1
P 017735 KNOB ......................................................
4 078338 SHAFT ASSEMBLY - Gap Control, QP, QPC and PRO ............. :
001980 PIN - Roll, ,135 O.D. x .640 O.A.L. ..................... 2
6” 101876 PIN - Roll, .135 0.0. x I.575 O.A.L. .................... 1
7 080448 CAM - O.S. .............................................. 1
8 001992 PIN - Roll, .135 O.D. x 1.015 O.A.L. .................... 2
9 *078337 SHAFT - Gap Control ..................................... 1
10 080449 CAM - N.O.S. ............................................
073551 DRAG - Gap Clamp ........................................ :
:: 150085 lYUT - l/4-28 .............................................. 1
193323 STUD - l/4-28 ..............................................
:; 101051 !UT - lo-32 ............................................... :
001702 lASHER - ,195 I.D. x .500 O.D. x ,029 .....................
:z 080452 :LAMP .................................................... :
18 077836 SPRING - Compression, .400 O.D. x .718 O.A.L. .............
19 077301 SCREW - Shoulder, lo-32 ................................... :
022783 TABLE ASSEMBLY - Master Load ..............................
if 007988 GUIDE ................................................... :
027291 SPRING - Strip .......................................... 2
:P 014463 RING - Retaining, .183 I.D. ............................. 4
24 001060 1ING - Retaining, .208 I.D. ...............................
25 007980 jHAFT - Table Support ..................................... :
* Uot Procurable Separately
84
1 025023 MASTER EJECTOR ASSEMBLY ..................................

195127 SCREW - Double Shoulder ................................ :
: 025446 SPRING - Tension, O.S. ................................
4 025447 SPRING - Tension, N.O.S. .............................. :
195185 BUSHING ................................................ 6
s 025233 GEAR ................................................... 1
7 025229 TIE ROD ................................................ 2
8 025226 ROLLER ASSEMBLY ........................................ 1
9 149329 PIN - Spiral, .105 O.D. X .635 O.A.L. ...............
10 025228 GEAR ................................................. :
011181 BEARING ................................................ 2
:: 074375 SCREW . Shoulder, l/4-28 ...............................
13 016783 SPRING - Tension, 1.250 O.A.L. ........................ 5
025220 FRAME ASSEMBLY - N.O.S. ...............................
:: 025216 FRAME ASSEMBLY - O.S. ................................. :
025231 SHAFT ..................................................
:; 025225 GEAR ................................................... :
18 084462 DRIVE WHEEL - Lower .................................... 2
014372 SCREW . Set, lo-32 X l/4 ............................... 4
:: 084461 DRIVE WHEEL - Upper ....................................
21 025224 SHAFT .................................................. :
22 011272 ROLLER ................................................. 4
100216 SCREW - Set, lo-32 X l/4 ............................... 4
I3 025210 CHUTE ASSEMBLY ......................................... 1
25 191826 WASHER - .313 I.D. X 9/16 O.D. .........................
025234 GEAR ................................................... ;
f f 001046 RING - Retaining, .292 I.D. ........................... 3
86
P* 0 00 nU

1 025207 UPPER GUIDE ASSEMBLY ...................................... 1

2 014216 SCREW - Shoulder, lo-32 ................................. 2
014754 wAShER - Spring, .260 I.D. .............................. 2
: 021203 WASHER - .254 I.D. ..................................... 2
5 084059 CLIP - Upper Guide, O.S. ...............................
011176 CLIP - Upper Guide, N.O.S. ............................. :
9 025208 GUIDE - Upper Ejection ..................................
8 195651 SCREW - Shoulder, l/4-28 .................................. :
9 195650 SPACER - Dowel Screw ......................................
025200 STRIPPER UNIT ASSEMBLY .................................... :
:: 004256 SPRING - Compression, .750 O.A.L. .......................
12 195181 SCREW - Shoulder, l/4-28 ................................ f
13 195184 BUSHING - Eccentric .....................................
100582 PIN - Roll, .135 O.D. X ,327 ............................ :
:: 025206 LATCH - Stripper ........................................
001095 RING - Retaining, .245 I.D. ............................ I
:f 025203 LATCH - Frame, O.S. .................................... 1
18 025204 LATCH - Frame, N.O.S. ..................................
025201 STRIPPER CHUTE ASSEMBLY ................................. :
:; 001730 WASHER - Lock, .291 I.D. X .500 O.D. X .030 ............. 2
21 013910 SUPPORT ASSEMBLY - Stripper ............................. 2
8
Part MODEL 986519869 - Figure 35 Units
193605 SPACER - Tie Bar .......................................... 1

007575 TIE BAR ...................................................
193601 SCREW - Shoulder Dowel, 5/16-24 O.S. ...................... :
084077 CAP - Ejection Housing ....................................
014275 SCREW - lo-32 X l/2 ....................................... :
192035 SPRING - Compression, .364 O.D. X 1.000 O.A.L. X .029 ..... 1
013933 PLUNGER AND PIN ASSEMBLY ..................................
101330 PIN - Roll, .136 O.D. X .635 O.A.L. .................... :
011195 HOUSING ................................................... 1
011194 EJECT CAM ASSEMBLY ........................................ 1
195191 PIN - .189 O.D. X .624 O.A.L. .............................
013931 GUIDE - Spring ............................................ :
195656 SPRING - Compression, .628 O.D. X l-21/32 O.A.L. ..........
013932 COVER - Spring ............................................ :
195189 WASHER - .327 I.D. X .725 O.D. X .032 ..................... 1
150087 NUT - 5116-24 .............................................
014515 RING - Retaining Plastic, .080 I.D. X .045 ................ :
084238 CABLE ASSEMBLY ............................................
192034 PIN - Solenoid, .125 O.D. X .920 O.A.L. ................... :
001047 RING - Retaining External, .340 I.D. X .027 ............... 1
012241 PULLEY - Cable,Upper ...................................... 1
100957 SCREW - l/4-28 X l/2 ......................................
192074 STUD - Pulley, l/4-28 ..................................... :
075074 PIN - Solenoid, .125 O.D. X .550 O.A.L. ...................
001094 RING - Retaining External, ,394 I.D. X .044 ............... :
084244 PULLEY - Cable, Lower .....................................
001594 SCREW - l/4-28 X l/2 ...................................... :
014788 WASHER - .260 I.D. X .625 O.D. X .093 .....................
191974 STUD - Pulley ............................................. :
014266 SCREW - l/4-28 X 11/16 ....................................
014807 NUT - l/4-28 .............................................. :
014208 SCREW . lo-32 X 518 .......................................
014808 NUT - lo-32 ............................................... :
084239 BRACKET ................................................... 1
014215 SCREW - lo-32 X 5/16 ......................................
021861 WASHER - .196 I.D. X .437 O.D. X .047 ..................... :
001706 WASHER - Lock, #lO ........................................ 4
059018 BUMPER . Soleniod ......................................... 1
100507 GROMMET ................................................... 1
001740 WASHER - Lock,l/4 ......................................... 1
90
Index
1
2
No.
Part
No.
193605
007575
SCREW . Special,
MODEL
5/16-24
9865/9869 - Figure
Description
36
..................................
TIE BAR ...................................................
Units
Per Assy
1
I.
3 073330 SCREW . Special, lo-32 .................................... :
4 192063 SCREW - Shoulder, l/4-28 (M-9865/69) ...................... 2
4 072349 SCREW - Eccentric, l/4-28 ........................ (M-9870) 2
5 016212 FRAME - Upper, O.S. (M-9865/69) ..........................
5 016206 FRAME - Upper, O.S. ............................. (M-9870) :
016213 FRAME - Upper, N.O.S. (M-9865/69) ........................
5 016207 FRAME - Upper, N.O.S. ........................... (M-9870) :
7 074324 BUSHING ASSEMBLY - Eccentric .............................. 1
8 196264 SCREW - Dowel, l/4-28 ..................................... 2
9 073140 SCREW - Pivot, 318-24 X 518 ............................... 1
10 111054 SCREW . lo-32 X l/2 ....................................... 4
021150 WASHER - .265 I.D. X .437 0.0. (M-9865/69) ................
:: 021268 WASHER - . 265 I.D. X .437 O.D. ................... (M-9870) 3
007745 GUIDE ..................................................... 3
:P 003578 NUT : ;;;-$; (M-9865169) ..................................
150085 NUT - ..................................... (M-9870) :
:2 074375 SCREW - Eccentric, l/4-28 (M-9865/69) .....................
15 012245 BLOCK - Eccentric, Spring (M-9865/69) ..................... :
072398 BLOCK - Eccentric, Spring ........................ (M-9870) 4
:6” 072424 SPRING - Compression, .537 O.D. X 1.343 O.A.L. ............ 2
193601 SCREW - Shoulder, 5/16-24 .................................
:: 025124 TIE BAR ................................................... :
21 074323 BUSHING ASSEMBLY . N.O.S. ................................. 1
22 014606 BUSHING - .629 I.D. X .753 O.D. X .630 O.A.L. ........... 1
23 001260 SCREW . Adjusting, lo-32 X l-1/4 .......................... 1
24 001812 KNOB ......................................................
25 017996 TIE BAR ................................................... :
008024 TIE BAR ................................................... 1
I; 007582 REST ASSEMBLY . (TD and CD) ............................... 1
191427 SCREW . Shoulder, 3/8-24 ..................................
E 194823 SCREW . Shoulder, 3/8-24 .................................. ;
30 111099 SCREW - 318-24 X 718 ...................................... 2
191428 WASHER - .510 I.D. X 1.000 O.D. ........................... 8
:: 013495 PLATE - Head Support - N.O.S. ............................. 1
150089 NUT - 318-24 .............................................. 8
3: 021911 WASHER . .578 I.D. X .875 O.D. ............................
35 084289 BUSHING . Eccentric ....................................... :
36 084291 SCREW . Shoulder, 3/8-24 .................................. 1
013494 PLATE - Head Support, O.S. ................................
z: 022839 GUIDE - Lateral, ................................. (M-9870) :
39 001047 RING - Retaining, ,340 I.D. x .027 ............... (M-9870) 4
40 022745 TRUNNION ......................................... (M-9870) 2
41 022746 YOKE - Trunnion, Mounting ........................ yw;j 2
42 111051 SCREW . lo-32 x 5/16 ............................. - 6
43 022748 TIE BAR ASSEMBLY ................................. 1
44 022844 GUIDE - Lateral O.S. ............................. I!-;:::;
- 1
45 022845 GUIDE - Lateral N.O.S. ...........................
46 014807 NUT - l/4 . 28 ................................... :
92
1 075644 STUD - Spring .............................................

064589 SPRING - Tension, .250 O.D. x 1.187 O.A.L. ................
3’ 073107 HOOK - Spring .............................................
4 193601 SCREW - Shoulder, 5/16-24 .................................
191034 STUD - Lockout Lever, l/4-28 ..............................
6” 071611 LEVER - Aquamatic Lockout .................................
7 001060 RING - Retaining, .208 I.D. ...............................
8 191935 STUD - Detent Lever .......................................
190631 WASHER - .275 I.D. x 9/16 O.D. ............................
;0 014808 NUT - lo-32 ...............................................
016206 FRAME - Upper, O.S. .......................................
:: 074324 BUSHING ASSEMBLY - Eccentric ..............................
001095 RING - Retaining, .245 I.D. ...............................
:3 071596 LINK - Control ............................................
15 071606 LEVER - Detent ............................................
001812 NUT - lo-32 ...............................................
:f 000666 JASHER - Lock, .194 I.D. x .281 O.D. ......................
064234 TRUCK - Detent Lever ......................................
:: 191934 STUD - Spring .............................................
20 020379 SPRING - Tension, .375 O.D. x 1.593 O.A.L. ................
21 193397 SPRING . Tension, ,390 O.D. x 1.281 O.A.L. ................
014350 SCREW - lo-32 x 5/16 ......................................
f5 071610 1ISC - Eccentric ..........................................
24 075537 :AM - Sequence Control ....................................
25 018062 lASHER - .328 I.D. x .625 O.D. ............................
26 001048 ?ING - Retaining, ,463 I.D. ...............................
28 100657 SCREW - lo-32 x 5116 ......................................
014372 SCREW - Set, lo-32 x l/4 ..................................
z: 001541 SCREW - 6-32 x l/4 ........................................
34 016941 -EVER - Overtravel ........................................
022343 SPRING - 3116 O.D. x 29/32 O.A.L. .........................
:z 016942 -EVER - Image Control .....................................
37 084407 STUD ......................................................
017819 (NOB ......................................................
z: 017744 -EVER - Control, ..........................................
40 100827 PIN - Spiral, . 168 O.D. x .635 O.A.L. ...................
196249 iCREW - Shoulder, l/4-28 ..................................
%: 191939 STUD - Spring .............................................
017481 flAGNET ASSEMBLY - Hall Effect .............................
1: 017477 PLATE ASSEMBLY - Sensor, Hall Effect ......................
45 017734 P. C. BOARD ASSEMBLY - Sensor, Hall Effect ................
94
1 014808 NUT - lo-32 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

190148 SPRING - Tension, .406 O.D. X 2.312 O.A.L. X .061 . . . . . . . . .
: 190768 STUD - Spring . . . . . . . . . . . . . . . . . . . .. . . . . . . . .. . . . . . . . . . . . . . . . :
4 014808 NUT - lo-32 ..*.........*..................................
5 080952 LEVER ASSEMBLY - Master Cylinder, (M-9865/69) ............. :
5 017627 LEVER ASSEMBLY - Master Cylinder, . . . . . . . . . . . . . . . . (M-9870)
6 081156 LEVER - (M-9865/69) . . . . . . . . . . . . .. . . . . . . . . . . . . . . . . . . . . . . . :
001818 NUT - l/4-28 . . . . . . . . .. . . . . . . . . . . . . . . . . . . .. . . . . .. . . . . . . . . 1
: 001740 WASHER - Lock, .262 I.D. X .500 O.D. X .025 . . . . . . . . . . . . .
9 072357 SCREW - Eccentric, l/4-28 . . . . . . . . . . . . . .. . . . . . . . . . . . .. . . . :
10 072358 TRUCK . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1
100891 SCREW - l/4-20 X 1.000 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
:: 001080 RING - Retaining External, .302 I.D. X .037 . . . . . . . . . . . . . . . :
13 025268 LEVER ASSEMBLY - Latch, (M-9865/69) . . . .. . . . . . . . .. . . . . .. . . . 1
13 072370 LEVER ASSEMBLY - Latch, . . . . . . . . . . . . . . . . . . . . . . . . . . (M-9870)
001821 NUT - l/4-28 . . . . . . . . . . . . . . . ..*............................ :
:z 072373 STUD - Latch Lever . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1
072511 SPRING - Tension, .250 O.D. X 1.125 O.A.L. X .018 . . . . . . . . . 1
:9 041777 SPRING - Tension, .312 O.D. x 1.344 O.A.L. . . . . . . . (M-9870)
18 001060 RING - Retaining, .208 I.D. x .527 O.D. x .027 . . . (M-9870) :
19 021203 WASHER - .254 I.D. x ,500 O.D. x .029 . . . . . . . . . . . . (M-9870) 1
001062 RING - Retaining, .250 I.D. x .027 . . . . . . . . . . . . . . . (M-9870) ;
z! 016574 WASHER - .315 I.D. x .687 O.D. x .047 . . . . . . . . . . . . (M-9870)
22 072386 LATCH LINK ASSEMBLY - Master Cylinder . . . . . . . . . . . . (M-9870)
195139 STUD - Spring, (M-9865/69) . . . . . .. .. .. . . . . . . . . . . .. . . . . . . . . . :
:3 017578 STUD - Latch Link ,................................ (M-9870)
150085 NUT - l/4-28 . . . . . . . . . .. .. . . . . . . . . . . . . . .. .. .. . . . . . . . . . . . . . . :
5: 072442 SPRING - Tension, .343 O.D. X 2.000 O.A.L. ,040 . . . . . . . . . . . 2
26 014727 WASHER - .382 I.D. X .750 O.D. .029 . . . . . . . . . . . . . . . . . . . ..a. 1
072040 LEVER ASSEMBLY - Power . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1
f; 192323 SCREW - Shoulder, l/4-28 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
29 072367 TRUCK . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . :
001446 BUSHING - .379 I.D. X .503 O.D. X ,875 . . . . . . . . . . . . . . . . . . 1
if 072369 STUD - Power Lever . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
32 072129 STUD - Spring . . . . . . . . . . .. . .. .. . . . . . . . . . . . . .. . . . .. . . . . . . . . . :
9(
P_ 0 0 00 nw
Index
No.
Part
***
No.
253474
253475
SWITCH ASSEMBLY
ACTUATOR
SWITCH
MODEL
- Doubles
- Pushbutton,Stop
- ZPST,Emergency
986519869 - Figure
Description
Detector
38
.......................
..............................
Stop ............................
.
Units
Per Assy
1
1
1
I.
253578 SOLENIOD . Master Latch, 115 VAC. 50/60 Hz. ............. 1
016916 KNOB ................................................... . 1
001207 SCREW - Set, 8-32 X 3/16 ............................... . 1
016541 ROD - Detector Switch Adj. .............................. 1
025237 BRACKET - Mounting ...................................... 1
001049 RING - Retaining, .227 I.D. X ,027 ......................
005071 WASHER - ,252 I.D. X ,027 ............................... :
196423 SPRING - Compression, 25/64 O.D. X 5" O.A.L. ............
016741 BRACKET - Stop .......................................... :
011948 PIVOT - Detector Adj. Rod ............................... 1
001588 SCREW - lo-32 X l/4 ..................................... 2
001772 WASHER . Friction, .376 I.D. X .750 O.D. ................ 1
014727 WASHER - .375 I.D. X .750 O.D. .......................... 1
100740 RING - Retaining, .357 I.D. X .045 ......................
190483 NUT PLATE - 2-56 ........................................ :
016739 BRACKET ASSEMBLY - Switch Mount ......................... 1
017159 INSULATOR - Switch Detector ............................. 1
192855 INSULATOR - Switch ...................................... 1
253025 SWITCH - S.P.D.T., 1 Amp 125 VAC. ....................... 1
100490 SCREW - 2-56 X l/2 ......................................
111033 SCREW - 8-32 X 5116 ..................................... 5
001586 SCREW - 8-32 X 5/16 ....................................... 2
196421 STUD - Switch Pivot, Chain Delivery ....................... 1
196420 STUD - Switch Pivot, Tray Delivery ........................
061452 SPACER .................................................... :
154078 NUT - Lock, l/4-28, Chain Delivery ........................
078363 PIVOT . Cradle Arm, Tray Delivery ......................... :
014511 RING . Retaining, .430I.D. X.,027 .........................
150089 NUT - 318-24 .............................................. :
111098 SCREW - 3/8-24 X 314 ......................................
150081 NUT - 8-32 ................................................ :
111036 SCREW - 8-32 X l/2 ........................................ 1
014515 RING - Plastic, .080 I.D. X .160 O.D. X ,025 .............. 2
190713 PIN - Solenoid ............................................
064673 SPRING - Tension, .250 O.D. X 1.578 O.A.L. X .024 ......... :
025127 LINK ASSEMBLY .............................................
021203 WASHER - .254 I.D. ........................................ :
001060 RING . Retaining, .208 I.D. X .027 ........................
022802 CABLE ASSEMBLY - Stop Switch, 18" ................ (M-9870) :
98
Index
0
No.
Part
No.
025019
007888
BLANKET
MODEL 986519869
WASHER ASSEMBLY
- Figure
Description
39
...................................
TIE BAR .................................................
Units
Per Assy
1
1
I.
: 001098 RING - Retaining, .339 I.D. X ,687 0.0. X .037 ..........
3 011010 CAM - Cradle ............................................ z
014247 SCREW - Set, lo-32 X l/4 ................................
k! 194574 SPRING - 19/64 O.D. X l-3/16 O.A.L. ..................... 1’
6 193817 STUD .................................................... 1
150085 NUT - l/4-28 ............................................ 3
: 025116 SHAFT ASSEMBLY - Cam ....................................
9 140023 PIN . Taper, .llO O.D. X .625 O.A.L. .................. :
011025 SIDE FRAME - R.H. .......................................
:: 074313 CLAMP - R.H. ............................................ :
12 193577 WASHER - Spring, .389 I.D. X .625 O.D. X .015 ........... 2
13 195013 SCREW - Shoulder ........................................ 1
14 007892 TIE BAR .................................................
15 100704 SCREW - 4-40 X 3/16 ..................................... :
080839 CLIP ....................................................
:; 007887 TIE BAR ................................................. :
18 011024 SIDE FRAME - L.H. ....................................... 1
19 193701 SCREW - l/4-28 X l/2 .................................... 4
20 074314 CLAMP - L.H. ............................................ 1
001650 SCREW - Set, lo-32 X 3/16 ............................... 1
;: 195194 STUD ....................................................
23 195193 STOP .................................................... :
24 150087 NUT . 5116-24 ........................................... 2
250358 :LAMP - l/2" ..............................................
I: 191176 TUBING . 3/8 I.D. X 33-l/8 O.A.L. ......................... :
073487 :LAMP - Hose ..............................................
z 011019 3RACKET ASSEMBLY . Mounting, N.O.S. ....................... :
008221 TROUGH ....................................................
z 025120 3RACKET ASSEMBLY - Mounting, O.S. ......................... :
001586 SCREW - 8-32 X 5/16 .......................................
:: 101334 -1TTING . Hose ............................................ 1’
091151 :AP ....................................................... 1
z 031748 :LAMP - Hose ..............................................
35 100593 SCREW - lo-32 X 9/16 ...................................... :
36 014808 UUT - lo-32 ............................................... 1
L 1 00
‘i/’ Index Part MODEL 9865/9869 - Figure 40 Units
025019 BLANKET WASHER ASSEMBLY ...................................

008227 ROLLER ASSEMBLY - Cleaning .............................. :
192853 SPACER - Roller .........................................
193703 SCREW - l/4-28 X l/2 .................................... :
007889 SHAFT - Roller .......................................... 2
008224 ROLLER ASSEMBLY . Scrubbing ............................. 1
011012 BRACKET - Roller, R.H. ..................................
011013 BRACKET - Roller, L.H. .................................. :
195151 STUD .................................................... 2
021203 WASHER . .254 I.D. ...................................... 2
011011 ROLLER ASSEMBLY .........................................
195150 BUSHING ............................................... :
150083 NUT - lo-32 ............................................. 2
194894 SPRING - 5/16 O.D. X l-15/32 O.A.L. .....................
*** WIPER ASSEMBLY .......................................... :
007867 BLADE ASSEMBLY ........................................ 1
007870 BRACKET ...............................................
041291 SPRING - Tension, 11/32 O.D. X 31/32 O.A.L. X .039 .... :
062704 LINK ..................................................
001552 SCREW - 8-32 X 5116 ................................... s
008218 SHIELD ................................................
007866 TIE ROD ............................................... :
001575 SCREW - lo-32 X 5/16 .................................. 2
195158 STUD .................................................. 2
008220 NOZZLE ASSEMBLY ....................................... 1
001825 NUT - 8-32 ............................................ 2
001586 SCREW . 8-32 X 5/16 ...................................
007893 ROLLER - Metering ....................................... :
“i, 192873 SCREW - Shoulder ........................................
008009 LEVER - Metering Roller ................................. :
191132 SPACER - .220 I.D. X 15132 O.D. X .093 ..................
008222 CRADLE ASSEMBLY ......................................... :
001812 NUT - lo-32 .............................................
001809 NUT - l/4-28 ............................................ :
012925 SCREW - Adjustment ......................................
040782 SPRING - Tension, .318 O.D. X I-7132 O.A.L. X .038 ...... ;
014276 SCREW - 8-32 X l/2 ...................................... 1
011372 KNOB ....................................................
016289 SPRING - Tension, .250 O.D. X .875 O.A.L. X .029 ........ :
012947 ANCHOR - Spring ......................................... 2
007875 SHIELD ASSEMBLY .........................................
001845 NUT - 318-24 ............................................ :
012846 BEARING - Roller ........................................
190601 WASHER - Shim, .256 I.D. X .375 O.D. X .005 ............. i,R
*** Not Salable As AN Assembly
102
1 181206 RING - Retaining External, .106 I.D. X ,250 O.D. X .015 ...
192870 PIN - Solenoid ............................................ :
3' 100442 RING - Retaining External, .lOO I.D. X .070 ...............
4 084143 LINK - Solenoid ........................................... :
012848 LINK - Solenoid ........................................... 1
z 191435 PIN - Solenoid Link .......................................
7 100134 SCREW . 8-32 X l/2 ........................................ :
8 250205 CLAMP - Cable, 3/16" ......................................
014811 NUT - 8-32 ................................................ :
;0 025108 LEVER - Blanket Cleaner Solenoid .......................... 1
014902 PIN - Taper, .125 O.D. X .750 ...........................
:: 025114 BRACKET ................................................... :
066763 BUSHING - Solenoid Lever ..................................
:: 192222 SPRING - Tension, .421 O.D. X 1.671 O.A.L. X .031 ......... :
014350 SCREW . lo-32 X 5/16 ......................................
:: 021861 WASHER - . 196 I.D. X .437 O.D. X .047 ..................... ::
001706 WASHER - Lock, #lO ........................................ 4
:; 025344 SOLENOID - Blanket Cleaner, 115 VAC. 50/60 Hz. ............ 1
104
P* 0 0 00 n fl

001552 SCREW . Knob .............................................. 1

: 016921 KNOB ...................................................... 1
3 025122 LEVER . Adjusting .........................................
4 150083 NUT - lo-32 ............................................... . k
194528 STUD - Adjusting Lever .................................... 1
z 194530 STUD . Adjusting Lever .................................... 1
194531 WASHER - .266 I.D. X .625 O.D. X .062 .....................
: 064674 SPRING -Compression, .392 O.D. X .687 O.A.L. X .053 ....... f
9 021150 WASHER - .254 I.D. X .625 O.D. X .029 ..................... 1
154078 NUT - l/4-28 .............................................. 1
:: 076882 HOllSING ASSEMBLY ..........................................
12 001473 BUSHING . .504 I.D. X .629 O.D. X .875 .................. :
001060 RING . Retaining External, .208 I.D. X ,027 ............... 1
:; 021203 WASHER - .255 I.D. X .029 .................................
15 014504 RING . Retaining External, .144 I.D. X .025 ............... :
013262 LEVER ASSEMBLY - Actuating ................................ 1
:; 081321 SPRING - Tension, .375 O.D. X 2.000 O.A.L. X .051 .........
18 013264 LINK ASSEMBLY . Solenoid .................................. :
194525 ANCHOR - Spring ...........................................
:x 021781 SPRING - Tension, ,203 O.D. X .906 O.A.L. X .018 .......... :
21 193553 SPACER .................................................... 1
22 014515 RING . Retaining, Plastic, .080 I.D. X .045 ............... 2
23 075074 PIN - Solenoid ............................................ 1
24 025341 SOLENOID . 120 VAC. 50/60 Hz. ............................. 1
111055 SCREW - lo-32 X l/2 ....................................... 3
I: 079764 CLAMP . Cable, 3/16" ...................................... 1
27 100110 RING . Retaining External, .474 I.D. X .053 ............... 1
28 001064 RING . Retaining External, .635 I.D. X .025 ............... 1
012927 ACTUATOR - Pump ........................................... 1
Pi 192862 TUBE . Pump Input ......................................... 1
150050 NUT - l/4-28 ..............................................
3: 012944 PUMP ASSEMBLY . Bellow .................................... :
012359 VALVE . Check, Threaded, lo-32 ............................ 2
Zd 012926 BRACKET - Pump Mounting ................................... 1
35 111071 SCREW - l/4-28 X l/2 ...................................... 2
014807 NUT - l/4-28 .............................................. 2
E 001090 RING . Retaining External,Bowed, .460 I.D. X .035 .........
101336 FITTING - Hose ............................................ :
z: 192866 TUBE - Pump Exit, 5/32 I.D. X 22” O.A.L. .................. 1
101234 CLAMP - Hose .............................................. 6
!Y 111053 SCREW . lo-32 X 7116 ...................................... 1
42 200049 CLAMP - Hose, l/4" ........................................ 2
014240 NUT - lo-32 ............................................... 1
t: 192867 TUBE . Input Pump, 5/32 I.D. X 3-l/2” O.A.L. .............. 1
012360 VALVE - Check .............................................
t: 072862 CLAMP . Hose, 314" ........................................ :
47 001275 SCREW - lo-16 X 518 .......................................
48 192868 TUBE . Supply, 5/32 I.D. X 26-5/8" O.A.L. ................. :
49 012945 FITTING . Tube ............................................ 1
50 091151 CAP --(1 Gallon) ..........................................
50 091045 CAP --(5 Liter) ........................................... :
012207 FILTER ASSEMBLY ........................................... 1
:: 001747 WASHER - .128 I.D. X .375 O.D. ............................ 2
106
P* 0 0 00 mm

*** CYLINDER ASSEMBLY - Blanket ...............................
: 018580 ROD - Clamp ............................................. :
018469 NUT - Clamp Rod, l/4-28 .................................
7 003586 WASHER - 7/8 I.D. X 3/4 O.D. X l/16 ..................... :
5 192054 SCREW - Blanket Cylinder, l/4-28 (M-9865/69) ............ 3
5 111073 SCREW - Shield, l/4-28 x 518 ................... (M-9870) 3
012163 CAM - Master Forwarding (Adjustable) ....................
F 195409 SCREW . Master Forwarding Cam ........................... :
8 100738 PIN - Roll, .069 O.D. X .265 ............................ 1
9 001052 WASHER - .203 I.D. X ,500 O.D. X .059 ...................
10 012244 WASHER - Adjusting Screw ................................ :
11 192058 SPRING - Compression, .415 O.D. X 1.062 O.A.L. X .070 . .
012242 GUIDE SPRING - Adjusting Screw, ,250 O.D. ............... :
:3 013436 CAM - Master Forwarding (Fixed) ......................... 1
14 101291 INSERT - lo-32 I.D. X .256 0.0. X .285 O.A.L. .........
012161 SPACER - Master Forwarding Cam .......................... :
:6” 009553 SHIELD - Blanket Cylinder ...................... (M-9870)
16 011140 END PLATE - Blanket Cylinder, (M-9865/69) ................. :
17 020138 SCREW - Shoulder Dowel,lO-32 ............................ 2
018575 RING ASSEMBLY - Blanket Cylinder, L.H. ..................
:; 018577 RING ASSEMBLY - Blanket Cylinder, R.H. .................. :
100508 SCREW - Drive, #00-3/16 O.A.L. ..........................
5: 080719 SCALE - Vertical Print Adjustment ....................... :
22 014157 SCREW - l/4-28 X 1.250 .................................. 2
078556 SCREW - l/4-28 X 1.187 .................................. 1
;t 025073 GEAR - Blanket Cylinder, (M-9865/69) .................... 1
009554 GEAR - Blanket Cylinder ........................ (M-9870)
;z 009551 CYLINDER - Blanket ...................................... :
26 100392 INSERT - l/4-28 I.D. X 3/8-16 O.D. ...................... 4
27 025074 GEAR - Vertical Print Adjust, (M-9865/69) ............... 1
009548 GEAR - Vertical Print Adjust ................... (M-9870)
;; 078552 INDICATOR - Vertical Print Adjusting ...................... :
018405 BLANKET BAR KIT ........................................... A/R
:; 014313 SCREW . Set, l/4-28 X 1.000 ............................. 4
31 007767 CLAMP - Body ............................................ 2
32 014151 SCREW - lo-32 X .500 .................................... 20
33 007766 CLAMP - Blanket .........................................
190236 SCREW - Blanket Clamp ,1/4-28 ..............................
014570 PIN - Drive Lock, 3/16 O.A.L. .............................

BLANKET - Supply Item 4-4124 Hard M-9865/69
BLANKET - Supply Item 4-4125 Compressible M-9870
1 08
1 014192 SCREW - 5/16-24 X 3/4 ..................................... 2

2 014721 lASHER - Lock, .326 I.D. X ,600 O.D. X .030 ............... 2
*** CYLINDER ASSEMBLY - Blanket ................................ 1
: 014748 lJASHER - .328 I.D. X 1.250 O.D. X.093 ..................... 2
009667 :AM ASSEMBLY - Blanket Cylinder N.O.S. ....................
: 078527 (EY - Woodruff, #505 ...................................... :
4 078551 SPACER - 1.000 I.D. X 1.500 O.D. X .259 ................... 1
001066 ?ING . Retaining,Internal, 2.320 O.D. X .081 .............. 1
: 078520 SEARING - .984 I.D. X 2.047 O.D. ..........................
10 111057 SCREW - lo-32 X 3/4 ....................................... :
11 150083 UUT - lo-32 ............................................... 3
012705 iOUSING - L.H. ,Bearing ................................... 1
:; 082103 \RM ASSEMBLY - Blanket Cylinder ...........................
14 017840 :AM ASSEMBLY - Blanket Cylinder O.S. ...................... :
15 078524 SPACER - 51/64 I.D. X 1.250 O.D. X .547 ................... 1
16 001065 1ING . Retaining,Internal, 2.089 O.D. X .065 .............. 1
17 078714 SEARING - .787 I.D. X 1.850 0.0. ..........................
18 111055 SCREW - lo-32 X 9/16 ...................................... :
19 150083 UUT - lo-32 ............................................... 6
20 082172 -lOUSING - R. H., Bearing ...................................
21 080718 SCREW - Special, 318-24 X I-7/16 .......................... :
22 007633 SHAFT . Blanket Cylinder ..................................
23 009558 'RINT ADJUSTING ASSEMBLY .................................. :
24 078542 BUSHING - .3BO I.D. X .562 O.D. X .750 O.A.L. ........... 1
25 078541 SPRING - Compression, .510 O.D. X 1.156 O.A.L. ..........
076856 HOUSING - Print Adjusting ............................... :
IS 014921 PIN - Roll, .I35 O.D. X .890 O.A.L. .....................
28 009559 ROD ASSEMBLY - Print Adjusting .......................... :
29 001987 PIN - Roll, .167 O.D. X .890 O.A.L. ...................
30 196248 SCREW - Special, lo-32 x 7/8 .............................. :
31 017739 <NOB - Print Adjusting .................................... 1
32 039642 ?ING - Vinyl, .135 x .075 ................................. 1
33 100649 SCREW . Flat Head, 5/16-24 X 3/4 .......................... 1
34 100647 dASHER - Tooth, 5/16 I.D. .................................
35 191482 dASHER - Special .......................................... :
11
Index
1
No.
Part
No.
191963 KEY . Pulley,

Description
3/16 Square
45
X l-3/8 ........................
Units
Per Assy
1
.1
001523 SCREW - Set, 5116-18 X 318 ...............................
5 083316 PULLEY ................................................... :
5 001847 NUT - Stop Elastic .......................................
100648 WASHER - Spring, .398 I.D. X 1.135 O.D. X .062 ........... :
! 100646 RING - Retaining, 1.653 I.D. X 1.769 O.D. X .065 .........
8 083317 WASHER - .645 I.D. X .812 O.D. X .029 .................... :
190179 BEARING - Ball, .6256 I.D. X 1.574 O.D. X .472 ...........
;0 080522 HOUSING - Bearing ........................................ :
11 191481 SPACER ................................................... 1
12 080191 PINION - Gear ............................................
100185 SCREW - (Nylok), lo-32 X .428 ............................ :
:1 014972 PIN - Roll, .182 X 15/16 .................................
15 025191 SHAFT .................................................... :
101333 PIN - Roll, .167 X 718 ...................................
:P 150083 NUT - lo-32 .............................................. ;
18 080247 HOUSING ASSEMBLY - Drive Shaft ........................... 1
014653 BUSHING - .628 I.D. X .722 O.D. X 1.250 ................
:8 111055 SCREW - lo-32 X 314 ...................................... :
21 011396 HANDWHEEL ................................................ 1
072655 DISC - Handwheel .........................................
ES 014171 SCREW - lo-32 X 314 ...................................... :
25 080376 HOUSING ASSEMBLY - Bearing ............................... 1
001416 BUSHING . .503 I.D. X .627 O.D. X 1.250 ................
Pf 072181 BEARING - Cam Shaft ...................................... :
31 196633 BELT -V, 4L560 ........................................... 1
32 022837 COVER - Cable .................................... (M-9870 1
112
_
.-_
-- -w Index Part MODEL 9865/9869 - Figure 46 Units
1 111055 iCREW - lo-32 x 9/16 ......................................

150083 IUT - lo-32 ............................................... 9
P 080376 IOUSING ASSEMBLY - l/2" Diameter Shaft .................... 1
4 001416 BUSHING - .504 I.D. x .627 O.D. x 1.000 O.A.L. .......... 3
072181 IOUSING ASSEMBLY ..........................................
: 111074 ;CREW . i/4-28 x 314 ...................................... :
a 005620 IASHER . .254 I.D. x 5/a O.D. x .059 ...................... 3
9 080378 iEAR ......................................................
014342 ;CREW - 10-32 x 5/a ....................................... :
:: 017487 ;HAFT ASSEMBLY - Cam, Hall Effect TD ...................... 1
11 017485 SHAFT ASSEMBLY - Cam, Hall Effect CD ...................... 1
12 *080414 CAM ..................................................... 1
13 000022 PIN - Taper, ,163 O.D. x .790 O.A.L. ....................
*072787 CAM . TD ................................................ :
:z 000023 PIN - Taper, .158 O.D. x .978 O.A.L. .................... 2
16 *017484 SHAFT ................................................... 1
17 *076084 CAM .....................................................
“072605 CAM ..................................................... :
:: 000024 PIN - Taper, .154 O.D. x 1.094 O.A.L. ................... 1
20 016380 ;EAR SHAFT ASSEMBLY . CD .................................. 1
072336 iEAR SHAFT ASSEMBLY . TD .................................. 1
f: 014902 PIN - Taper, .llO O.D. x .720 O.A.L. .................... 2
22 001992 PIN - Roll . . 135 O.D. x 1.015 O.A.L. TD (Old Design) ...... 1
22 101333 PIN - Spiral, .136 O.D. x .947 O.A.L., CD (Old Design) ..
22 000012 PIN - Taper, .123 O.D. x .998 O.A.L. .................... :
23 *071625 GEAR - TD ............................................... 1
23 *078445 GEAR - CD ...............................................
24 *07233a GEAR .................................................... :
Y--j 25 *072337 SHAFT ...................................................
192273 SPACER - TD ............................................. :
:5 072333 10USING ASSEMBLY .................. . ....................... 1
28 001404 BUSHING - .379 I.D. X .504 O.D. X .500 O.A.L. ........... 2
001567 iCREW - 114-28 x 3/a ...................................... 2
z"7 017478 %RACKET ASSEMBLY - Clock, Hall Effect ..................... 1
250205 :LAMP - Cable, 3/16 .......................................
E 000895 jCREW - Thread Forming, 6-32 X 3/8 ........................ :
40 025303 iARNESS ASSEMBLY .......................................... 1
001541 jCREW . 6-32 x 318 ........................................ 2
41
017742 ). C. BOARD ASSEMBLY . Clock/Sync., Hall Effect ...........
t: 014108 SCREW . Set, lo-32 x 3/8 .................................. :
44 017480 JHEEL ASSEMBLY - Hall Effect .............................. 1
L-..--’
‘**009650 CYLINDER ASSEMBLY - Impression, CD ........................ 1

k**009670 CYLINDER ASSEMBLY - Impression, TD ........................
4 :
014165 SCREW - l/4-28 x 1.000 ..................................
007764 BEARING BLOCK . Gripper .................................
014205 SCREW . lo-32 x 13/16 ................................... :
014808 NUT - lo-32 ............................................. 6
007731 FINGER - Gripper Impression Cylinder .................... 2
007986 FINGER - Gripper Impression Cylinder ....................
007984 PAPER STOP - Gripper Impression Cylinder ................ :
007613 GRIPPER SHAFT ASSEMBLY .................................. 1
*007614 GRIPPER SHAFT ......................................... 1
*007664 LEVER ASSEMBLY ........................................
190111 PIN - Taper ........................................... :
007762 STRIPPER FINGER ASSEMBLY - Tray Delivery ................
*078729 ARM . Truck ........................................... :
*070226 STUD . Spring ......................................... 1
*072441 QIVET .................................................
072367 TRUCK ................................................. :
072366 BUSHING ............................................... 1
*007763 FINGER - Stripper ..................................... 1
191360 STUD - Spring ........................................... 1
100130 SCREW - Set, lo-32 x 1.000 .............................. 1
081104 ARM - Overload .......................................... 1
190135 SPRING - Compression, .350 O.D. x 1.000 O.A.L. x .045 ... 1
194804 PIN - Special ...........................................
078744 SPRING - Tension, .406 O.D. x 1.937 O.A.L. x .049 ....... :
014504 RING . Retaining, .146 I.D. x .338 O.D. x .027 .......... 2
191401 SPRING - Tension, 13/32 O.D. x l-5/16 O.A.L. x .036 ..... 1
001095 RING - Retaining, .250 I.D. x l/2 O.D. x .027 ...........
082131 PIN - Special ........................................... :
081106 TRUCK - Special ......................................... 1
190107 TRUCK - .190 I.D. x l/2 O.D. x .240 .....................
001075 SING - Retaining, ,397 I.D. x ,037 ...................... :
082135 ARM - Operating ......................................... 1
190149 WASHER . .440 I.D. x 11/16 O.D. x .029 .................. 1
014516 RING - Retaining, 2-7/16 O.D. x .081 ....................
080814 BEARING - Ball, 1.1811 I.D. x 2.440 O.D. x .6299 ....... ( :
078520 BEARING - Ball, .9843 I.D. x 2.0472 O.D. x .5906 ...... .
001066 RING - Retaining, 2.250 O.D. x .081 ..................... :
078712 CAM ..................................................... 1
009652 GEAQ . Impression Cylinder ............................. . 1
009651 CYLINDER . Impression, CD ............................... 1
009671 CYLINDER - Impression, TD .............................. .
076100 SPRING ANCHOR . Tray Delivery .......................... . :
-193982 ,. SPRING - Tension, .312 O.D. x .781 O.A.L. x .031 - TD ..
196669 STUD - fray Delivery ................................... :
191361 STUD - Chain Delivery ..................................
014157 SCREW - l/4-28 x l-1/4 ................................. . :
082128 COLLAQ - l-11/16 O.D. x 1.183 I.D. x 2-5/32 O.A.L. ..... . 1
014206 SCREW - Set, l/4-28 x 318 ..............................
193383 SHIM - .443I.D. x .625 O.D. x .005 ............. (M-9870 i/R
196318 SHIM - .443I.D. x .625 O.D. x .003 ............. (M-9870 A/R

*** Not Available As An Assembly
116
No. No. Description ‘er Assy.
1 080496 ;TUD - Support Arm ........................................ 2

001845 rlUT - 318-24 .............................................. 2
P 080495 lASHER - Lock, 25/64 I.D. x l-1/4 O.D. x .119 ............. 2
4 014121 SCREW - 3/8-24 x 1.000 ....................................
150089 IUT - 318-24 .............................................. 5
; 014172 ;CREW - l/4-28 x 3/4 ...................................... 2
001821 IUT - l/4-28 .............................................. 2
L 080621 ;UIDE - Support Arm Spring ................................ 2
9 078728 SPRING - Compression ...................................... 2
10 014173 iCREW - 5/16-18 x l-1/4 ...................................
11 080447 ‘IN - Separator ........................................... :
12 001840 'JUT - 5/16-18 ............................................. 2
13 080486 iLOCK ASSEMBLY . Support Arm, Impression Cylinder ......... 2
001981 PIN - Roll, .199 O.D. x .827 O.A.L. .....................
:: 080498 jUPPORT ARM - Impression Cylinder ......................... ;
16 016158 iCREW - Shoulder, lo-32 x .273 ............................ 1
17 001649 SCREW - lo-32 x .500 ...................................... 2
18 007729 :AM ASSEMBLY - Gripper, TD ................................ 1
18 082129 :AM ASSEMBLY - Gripper, CD ................................ 1
19 100296 SCREW - Set, l/4-28 x .500 Sq. Hd. ........................ 2
20 081037 :AM ASSEMBLY - Stripper, TD ............................... 1
21 007609 SHAFT - Impression Cylinder ...............................
22 014517 3ING - Retaining, 1.039 I.D. x .052 ....................... :
118
P* 0 00- mm
\
‘d Index
No.
Part
No.
196236
150083
MODEL
STUD - Spring Anchor

9865/9869 - Figure
Description
49
......................................
NUT - lo-32 ...............................................
Units
Per Assy
:
2
I
111033 SCREW - 8-32 x 5/16 .......................................
009665 BRACKET - Mounting ........................................ 1
253375 SOLENOID - 115 VAC. 50/60 Hz. .............................
009662 LEVER ASSEMBLY - Imp. Cyl. Latch .......................... :
014174 SCREW - lo-32 x 5/8 .......................................
014515 RING - Vinyl, .080 I.D. x .160 ............................ :
190713 PIN - Solenoid Link .......................................
111054 SCREW . lo-32 x l/2 ....................................... :
072442 SPRING - Tension, .343 O.D. x 2.000 O.A.L. ................ 2
001080 RING - Retaining, .302 I.D. x .660 O.D. x .037 ............ 1
014727 WASHER - .385 I.D. x .760 O.D. x .032 ..................... 1
072362 POWER LEVER ASSEMBLY - Impression Cylinder ................
001446 BUSHING - .503 O.D. x ,379 I.D. x .875 O.A.L. ........... :
192323 SCREW - Eccentric, l/4-28 x l/4 ......................... 1
072367 TRUCK ...................................................
150085 NUT - l/4-28 .............................................. :
196237 STUD - Power Lever ........................................ 1
072413 SPRING ANCHOR - Power Lever ...............................
072354 LEVER ASSEMBLY - Impression Cyl. Separator ................ :
071561 LEVER - Impression Cyl. Separator .......................
072357 PIN - Eccentric ......................................... :
072358 TRUCK - Impression Cyl. Separator Lever ................. 1
001818 NUT - l/4-28 ............................................
001740 WASHER - Lock, .267 I.D. x .506 0.0. x .D30 ............. :
100891 SCREW - l/4-20 x 1.000 .................................. 1
._
014808 NUT - lo-32 ...............................................
196235 STUD - Spring, l-13/16 O.A.L. ............................. :
064673 SPRING - Tension, .375 O.D. x 1.375 O.A.L. ................
041774 SPRING - Tension, .250 O.D. x ,781 O.A.L. ................. :
001046 RING - Retaining, .283 I.D. x .027 ........................ 2
009664 LEVER ASSEMBLY . Impression Cyl. Latch Lever ..............
072378 BEARING - Impression Cyl. Latch Lever ..................... :
014248 NUT - lo-32 ...............................................
022833 CABLE ASSEMBLY - Impression Sol. 36" ............. (M-9870) :
:_:
014808 NUT - lo-32 .............................................. 1

190768 STUD - lo-32 ............................................. 1
101051 NUT - lo-32 .............................................. 1
001702 WASHER - .195 I.D. x .500 O.D. x .029 ....................
077836 SPRING - Compression, .400 O.D. x .718 O.A.L. ............ :
080452 CLAMP - W/Teeth .......................................... 2
077301 SCREW - Shoulder, lo-32 ..................................
150085 NUT - l/4-28 ............................................. :
193323 STUD - l/4-28 ............................................
017815 SHAFT ASSEMBLY - Gap Control ............................. :
*017816 SHAFT - Gap Control ....................................
073551 DRAG - Gap Clamp ....................................... :
141573 PIN - Roll, .199 0.0. x .890 O.A.L. ....................
*072169 DIAL ................................................... :
001992 PIN - Roll, .135 O.D. x 1.015 O.A.L. ................... 2
080448 CAM - R.H. .............................................
080449 CAM - L.H. ............................................. . :
001980 PIN - Roll, ,135 O.D. x .640 O.A.L. .................... .
195421 Allen Key For Adjusting Gap Control ...................... . :
195142 PULLEY - Nylon ...........................................
100110 RING - Retaining, .474 I.D. X .768 O.D. X .053 ........... :

1 193601 SCREW - Shoulder, 5/16-24 .................................

016210 FRAME - Machine, N.O.S. (M-9865/69) .......................
5 016205 FRAME - Machine, N.O.S. .......................... (M-9870)
3 007575 TIE BAR - CD, .............................................
8 150081 NUT - 8-32 ................................................
10 111036 SCREW - 8-32 x l/2 ........................................
11 072055 GUARD - R.H. ..............................................
072056 GUARD - L.h. ..............................................
:s 111073 SCREW - l/4-28 x 5/8 ......................................
14 150085 NUT - l/4-28 .............................................. 12
195296 SCREW - l/4-28 x 3/4, Tray Delivery ....................... 8
:5 011055 BRACKET - Foot, O.S. ...................................... 2
18 011056 BRACKET - Foot, N.O.S. ....................................
011229 BRACKET - Foot, Center .................................... 2'
:: 016211 FRAME - Machine, O.S. (M-9865/69) ......................... 1
20 016204 FRAME - Machine, O.S. ............................ (M-9870)
193808 SPACER - .343 I.D. x 9/16 x .125 .......................... :
2’: 111089 SCREW . 5/16-24 x 5/8 ..................................... 2
23 190116 STOP - Height Regulator ...................................
24 001824 NUT - Lock, 5/16-18 ....................................... :
25 196393 SCREW - Dowel, l/4-28 x 5/8 - Chain Delivery .............. 4
1 080396 LEVER ASSEMBLY - Table Raising ............................ 1

014921 PIN - Roll, .135 O.D. x .890 O.A.L. ..................... 1
f *080400 LEVER ...................................................
4 *080397 LEVER ................................................... :
080404 LEVER . Adjusting .........................................
6” 150085 VUT . l/4-28 .............................................. :
080409 PIVOT PIN ................................................. 1
: 011405 LEVER ASSEMBLY - Dwell Control ............................
9 081152 LEVER ................................................... :
10 072052 SPRING LOCK .............................................
11 011371 HANDLE .................................................. :
015034 SCREW . lo-32 x l/2 .......................................
:f 150083 lUUT . lo-32 ............................................... :
14 080402 3EARING ASSEMBLY - Table Raising Lever .................... 1
15 001412 BUSHING . .441 I.D. x .565 O.D. x ,375 O.A.L. ........... 2
16 072511 SPRING - Tension, .250 O.D. x 1.125 O.A.L. ................ 2
17 001047 ?ING - Retaining, .340 I.D. x .033 ........................
18 072481 STUD . lo-32 .............................................. :
19 072478 LEVER ASSEMBLY - Contact .................................. 1
20 080032 LEVER ASSEMBLY - Lower Latch .............................. 1
21 072482 SPRING ANCHOR - Contact Lever Spring ...................... 1
121
001542 SCREW - lo-32 x 7116 ..................................... 1

: 080184 PLATE .................................................... 1
072561 MITER AND SPUR GEAR ......................................
7 007937
194805
STUD . Miter and Spur Gear ...............................
SCREW . Shoulder, 3/8-24 .................................
:
F
8
072610
150089
STUD - Table Release
NUT - 318-24
Lever, 318-24 .......................
.............................................
:
9 080408 SCREW . 5/16-24 .... ..K ................................. :

10 080410 SPRING - Compression, .728 O.D. x 1.062 O.A.L. ........... 1
11 001797 MASHER - . 515 I.D. x ,812 O.D. x ,059 ....................
12 080407 STUD . Table Release Lever Spring ........................ :
014810 NUT - 3/8-24 ............................................. 1
:2 072626 SPRING - Tension, .300 O.D. x .937 O.A.L. ................ 1
041291 SPRING - Tension, .343 O.D. x .968 O.A.L. ................
:; 013827 TABLE RELEASE LEVER ASSEMBLY ............................. :
17 001047 SING . Retaining, .340 I.D. x .027 ....................... 2
041777 SPRING - Compression, .312 O.D. x 1.344 O.A.L. ...........
:: 072484 UPPER LATCH LEVER ........................................ :
:ndex
No.
1
2
Part
No.
001075
190149
RING - Retaining,
WASHER
Description
54
.397 I.D. x .027 ........................

- ,441 I.D. x .687 O.D. x .029 .....................
Units
Per Assy
1
1
3
007743 LEVER ASSEMBLY - Forwarding ...............................
: 001493 BUSHING ................................................. :
*072790 RIVET ................................................... 1
! 072176 TRUCK ...................................................
7 072175 BUSHING ................................................. :
8 150089 NUT - 318-24 ..............................................
9 190110 STUD - Forwarding Lever Assembly .......................... :
10 078744 SPRING - Tension, .406 O.D. x 1.937 O.A.L. ................
11 001047 RING - Retaining, .340 I.D. x .027 ........................ :
072199 HUB ASSEMBLY - Buckle Adjustment ..........................
:G 150085 NUT - l/4-28 .............................................. :
14 072201 STUD - Buckle Ad,justment Hub ..............................
15 014808 NUT - lo-32 ............................................... :
16 072186 SPRING ANCtiOR - Buckle Adjustment Hub Spring .............. 1
17 001847 NUT - 318-24 .............................................. 1
016574 WASHER - .315 I.D. x .687 0.0. x .047 ............ (M-9870)
:: 072382 LEVER ASSEMBLY - Counter Operating ............... (M-9870) :
20 014844 NUT - 8-32 .............................................. 1
21 001722 WASHER - Lock, .172 I.D. x .375 O.D. x .020 .............
22 072427 PIN - Eccentric ......................................... :
23 014219 SCREW - l/4-20 x 3/4 ...................................... 1
24 005071 WASHER - .253 I.D. x ,500 O.D. x .059 ..................... 1
072383 LEVER - Counter Operating, (M-9865/69) ....................
z 073333 SPRING - Tension, .296 O.D. x 1.187 O.A.L. ................ :
27 072488 LEVER ASSEMBLY - Double ................................... 1
28 001691 SCREW - lo-32 x l/4 . . . . . . . . . . . . . .......................... 2
29 072491 PLATE - Contacting Regulator . . . . .......................... 1
30 072482 SPRING ANCHOR - Double Lever Spr i ng ....................... 1
31 080153 STUD - Double Lever . . . . . . . . . . . . . ..........................
32 196247 SCREW - Special, lo-32 x l-1/8 . . .......................... :
33 k**017806 KNOB ASSEMBLY - Buckle Adjusting ..........................
34 014529 SCREW - Drive, #2 x l/4 . . . . . . . .......................... :
35 017750 DIAL - Buckle Adjusting Knob ............................ 1
36 017738 KNOB - Buckle Adjusting ................................. 1
37 039642 RING - Vinyl, .155 I.D. x ,075 ............................ 1
38 076605 CAM SHAFT AND HOUSING ASSEMBLY ............................
39 001046 RING - Retaining, .283 I.D. x .027 ...................... :
40 195645 WASHER - Spring, .324 I.D. x .510 O.D. x .085 ...........
42 072207 HOUSING ASSEMBLY - Cam .................................. :
43 072205 SHAFT ASSEMBLY - Cam .................................... 1
001990 PIN - Roll, .135 O.D. x .515 O.A.L. ...................
:k! 014902 PIN - Taper, .llO O.D. x ,720 O.A.L. .................. :
014149 SCREW . lo-32 x 11/16 .....................................
f P 150083
001062
NUT - lo-32 ...............................................
RING . Retaining, .258 I.D. x .027 ............... (M-98701
:
1
48

*** Not Available As An Assembly
130
‘\‘._/’
1 001047 RING - Retaining, .340 I.D. x -027 ........................ 7

2 001075 RING . Retaining, ,397 I.D. x ,027 ........................ 1
014703 WASHER - .384 I.D. x .562 O.D. x ,029 ..................... 4
3 190149 WASHER - .441 I.D. x .687 O.D. x .029 ..................... 2
072177 LEVER ASSEMBLY - Follower, Feed ........................... 1
2 001412 BUSHING - ,441 I.D. x .565 O.D. x ,375 O.A.L. ........... 2
*072790 RIVET ................................................... 1
; 072176 ROLLER ..................................................
9 072175 BUSHING - .220 I.D. x .313 O.D. x .324 O.A.L. ........... :
10 111035 SCREW - 8-32 x 7116 ....................................... 6
11 072243 LINK ASSEMBLY - Feed, Long ................................
072233 ADJUSTING PLATE ASSEMBLY .................................. :
:; 001404 BUSHING - .379 I.D. x .504 O.D. x .500 .................. 2
14 072189 LINK ASSEMBLY . Buckle Adjusting .......................... 1
072210 BEARING - .380 I.D. x .750 O.D. ........................... 1
:6” 072230 LINK ASSEMBLY - Forwarding, Short .........................
072239 LEVER ASSEMBLY - Feed Forwarding .......................... :
:: 196233 STUD - Lever .............................................. 1
076887 BRACKET-Stop .............................................. 1
:: 009530 S;;;" ASSEMBLY - ..........................................
21 072534 - Eccentric .......................................... :
22 150085 NUT . l/4-28 .............................................. 2
23 195140 SCREW - Shoulder ..........................................
196469 SPRING - Tension, 19/64 O.D. x 1 17/32 O.A.L. ............. :
f f 009527 SOLENOID BRACKET .......................................... 1
253578 FEED SOLENOID . 115 VAC. 50/60/Hz. ........................
;; 009531 LINK ...................................................... :
192181 SPRING .................................................... 1
28
190713 PIN - Solenoid ............................................
PX 014515 RING - Plastic, .080 I.D. X 160 O.D. X .025 ............... :
31 014807 NUT - l/4-28 ..............................................
32 014504 RING - Retaining, .146 I.D. X ,027 ........................ :
021563 WASHER - .194 I.D. ........................................ 1
:: 111033 SCREW . 8-32 X 5116 .......................................
072442 SPRING - Tension, .343 0.0. X 2.000 O.A.L. ................ :
35
36 022824 CABLE ASSEMBLY - Feed Sol. 16" ................... (M-9870) 1

P* 0 0 00 wm

No. No. Description Jer Assy.
001095 ?ING - Retaining, .245 I.D. x .500 O.D. x .027 ...........

073373 -INK ASSEMBLY ............................................ 1
001472 BUSHING ................................................ 2
073381 SPRING - .500 O.D. x 4.687 O.A.L. ......................
001049 1ING - Retaining, .227 I.D. x .027 ....................... :
072471 3USHING .................................................. 1
072472 3USHING ..................................................
072589 -EVER ASSEMBLY ........................................... :
001469 BUSHING ................................................
072512 SPRING - .343 O.D. x 3.031 O.A.L. ........................ :
041777 SPRING - .312 O.D. x 1.344 O.A.L. ........................
072504 -INK ASSEMBLY ............................................ :
025134 iAND CRANK ASSEMBLY ...................................... 1
017715 HANDLE .................................................
003042 SPRING LOCK ............................................ :
014909 PIN - Roll, .264 O.D. x .702 O.A.L. .................... 1
* HAND CRANK WITH STUD ...................................
001048 RING - Retaining, .463 I.D. x .037 ....................... :
017644 RATCHET AND GEAR ASSEMBLY . 32 Tooth ..................... 1
014158 SCREW - lo-32 x l/2 .................................... 3
080144 GEAR ...................................................
017645 RATCHET - 32 Tooth ..................................... :
072544 SPRING - .406 O.D. x 3.125 O.A.L. ........................ 1
064590 SPRING - .218 O.D. x .937 O.A.L. .........................
072586 SCREW - Shoulder, l/4-28 ................................. :
150085 NUT - l/4-28 .............................................
072580 ANCHOR - Spring .......................................... :
017647 PAWL ASSEMBLY ............................................ 1
072576 LEVER ASSEMBLY ........................................... 1
001470 BUSHING ................................................ 1
072579 STUD - Spring ............................................
072621 STUD ..................................................... :
001080 RING - Retaining, .302 I.D. x .660 0.0. x .037 ...........
075836 PAWL ..................................................... :
192202 WASHER - .385 I.D. x .625 O.D. x .OlO .................... 1
001094 RING - Retaining, .388 I.D. x .800 O.D. x .040 ...........
010142 LINK .................................................... :
001785 RING - Crescent, .880 I.D. x 1.130 O.D. x .044 ...........
017125 KNOB ..................................................... :
054147 SCREW - Shoulder, 8-32 ................................... 1
006987 SPRING . .296 O.D. x 1.468 O.A.L. ........................
017783 METAL CAL ................................................ :
190329 SPRING - Compression, 13132 O.D. x 3/8 O.A.L. ............ 1
072620 SCREW - Shoulder, lo-32 .................................. 1
194868 SPACER - .520 I.D. x .687 O.D. x .125 ....................
017151 SHAFT ASSEMBLY . Table Raise ............................. :

080334 MITER AND WORM GEAR ASSEMBLY .............................. 1

: 100966 PIN - Spiral, .182 O.D. x .822 O.A.L. ................... 1
3 *081607 GEAR ....................................................
4 001920 PIN - Taper, .149 O.D. x .786 O.A.L. .................... :
*072636 GEAR - Worm .............................................
6” *072574 SHAFT ................................................... :
080337 BRACKET - Miter and Worm ................................
: 072575 SCREW - l/4-28 ............................................ :
9 001555 SCREW - lo-32 x l/2 ....................................... 6
014248 NUT . lo-32 ............................................... 6
:: 072599 BEARING ASSEMBLY .......................................... 2
13 017151 SHAFT ASSEMBLY - Table Raising ............................
14 149385 PIN - Spiral, .152 O.D. x 1.250 O.A.L. .................. :
*080336 GEAR ....................................................
:z 001936 PIN - Taper, 1.250 O.A.L. ............................... :
“072041 SPROCKET ................................................
:: *017150 SHAFT ................................................... :
19 072035 CHAIN ASSEMBLY - Table Raising ............................ 2
20 071576 LINK . Master ...........................................
072077 WEIGHT ASSEMBLY ........................................... :
f : 194835 HOOK .................................................... 1
136
*** WORKLIGHT -ASSEMBLY - Flexible, 115 V. .....................

101921 POST - 318 - 16 .........................................
190699 WASHER - .390 I.D. x 1.250 O.D. x .097 ..................
101922 NUT - 318-16 ............................................
017137 aRACKET - Lamp, TD ........................................
196393 SCREW . l/4-28 x 5/8, TD ..................................
150085 NUT - l/4-28 ..............................................
251520 BUSHING - Plastic, l/2 O.D. ...............................
*** 3rder as Product Number l-3582
208
I Part Fig.6 Part F1g.L Part Fig.6 Part Fig .6
Number Index Number Index Number Index Number Index
000006 14A-13 001052 30-30 001095 14-17 001432 19-37
000008 16-7 001052 43-9 001095 24-37 001432 85-2
t- 000009 6-5 001054 84-13 001095 31-16 001446 37-30
000009 8-27 001060 6-8 001095 31A -28 001446 49-18
000009 16-9 001060 7-7 001095 34-16 001469 56-9
000009 238-4 001060 12A-17 001095 36A-13 001470 56-30
000009 82-31 001060 19-51 001095 47-28 001472 56-3
000011 20-12 001060 24-l 001095 56-l 001472 83-17
000012 46-22 001060 28-22 001095 66-33 001473 42-12
000014 13-2 001060 29-15 001095 83-18 001493 54-4
000014 60-l 5 001060 31A -10 001095 85-11 001495 60-17
000014 84-16 001060 32A-24 001095 86-19 001497 13-28
000020 19-27 001060 36A-7 001096 lo-25 001497 20-2
000020 59-22 001060 37-18 001097 21A-2 001497 22-20
000022 46-13 001060 38-38 001097 30-21 001497 23C-33
000023 46-l 5 001060 42-13 001098 19-25 001523 45-2
000024 46-19 001060 63-15 001098 29-39 001523 65-10
000024 66-26 001060 71-26 001098 39-2 001523 69-30
000666 36A-17 001060 86-2 1 001099 11-3 001525 73-l
000895 46-39 001060 88A-3 7 001099 llA-5 001536 29-18
000895 64-2 001060 90-18 001106 29-13 001541 19-48
001044 21A-34 001062 37-20 001106 31A-8 001541 36A-33
001044 62-12 001062 54-48 001106 59-27 001541 46-41
001046 21-36 001064 42-28 001129 7-10 001541 64-14
001046 21A-36 001065 44-16 001207 13-38 001541 73-33
001046 33-27 001066 44-8 001207 23C-25 001541 82-36
001046 49-37 001066 47-38 001207 31A-23 001542 53-l
001046 54-39 001067 58-23 001207 38-5 001542 59-11
001046 59-18 001073 7-14 001220 4-28 001542 64-8
001046 61-25 001074 58-22 001220 64-20 001543 7-12
001046 79-21 001075 236-6 001220 88A-32 001548 75-24 L,
001046 80-16 001075 47-32 001221 17-25 001552 40-19
001047 5-18 001075 54-l 001221 72-34 001552 42-1
001047 19-22 001075 55-2 001259 2-4 001552 70-10
001047 24-29 001076 21-24 001260 20-20 001552 71-30
001047 30-24 001076 21A-24 001260 36-23 001552 72-18
001047 35-21 001076 81-10 001267 62-9 001552 85-19
001047 36-39 001076 83-22 001275 42-47 001555 6-14
001047 52-17 001080 11-6 001279 4-2 001555 57-9
001047 53-17 001080 llA-14 001289 14-28 001555 70-18
001047 54-l 1 001080 14A-6 001289 25-18 001563 65-30
001047 55-l 001080 16-24 001289 72-32 001563 75-9
001047 58-4 001080 22-2 001401 62-32 001565 59-9
001047 61-8 001080 25-2 001404 16-19 001565 73-7
001047 62-24 001080 37-12 001404 29-23 001567 14-44
001047 85-21 001080 49-15 001404 46-28 001567 46-36
001048 13-15 001080 56-33 001404 55-13 001573 18-25
001048 22-28 001080 58-3 001404 62-21 001575 8-6
001048 25-27 001080 59-14 001404 62-27 001575 28-48
001048 36A-26 001080 86-15 001409 63-17 001575 40-22
001048 56-18 001080 88-42 001412 29-36 001577 23-21
001048 62-15 001090 25-25 001412 52-15 001577 23A-14
001048 66-21 001090 42-37 001412 55-6 001586 26-15
001049 5-14 001094 14-14 001413 20-9 001586 27-6
001049 19-17 001094 14A-30 001413 21-30 001586 38-24
001049 31-29 001094 19-7 001413 21A-30 001586 39-31
001049 38-8 001094 21A-14 001413 62-18 001586 40-26
001049 56-5 001094 28-38 001416 lo-23 001586 69-34
001049 61-23 001094 32-9 001416 45-26 001586 70-4
001049 80-9 001094 35-27 001416 46-4 001586 71-4
001049 83-8 001094 56-36 001420 81-16 001586 73-20
001049 85-29 001094 81-27 001427 23B-18 001588 24-10
001052 17-26 001094 86-9 001429 28-34 001588 25-28 ‘\_-
001052 26-5 001095 12A-27 001430 29-22 001588 31A-31
209
Part Fig.6 Part Fig.& Part Fig .6 Part Fig.6
38-14 001980 68-37 00X7-T _
001588 38-13 001772
001588 70-7 001776 31-26 001981 48-14 007577 23C-34
001588 71-Z 001776 82-19 001981 85-7 007580 13-26
001590 70-16 001778 13-36 001983 84-18 007580 23C-35
001594 6-13 001782 25-33 001984 59-24 007581 13-29
001594 35-29 001784 28-12 001986 32-21 007582 12-17
001603 3-3 001784 81-13 001987 19-2 007582 36-27
001606 68-25 001785 ZlA-33 001987 44-29 007591 19-33
001609 68-12 001785 56-38 001987 60-13 007599 23-l
001611 70-35 001797 22-27 001990 14-25 007599 23A-21
001631 2-4 001797 53-11 001990 54-44 007601 60-l
001631 2-33 001804 13-22 001990 68A-7 007601 67-3
001649 30-4 001809 40-33 001991 31-43 *007602 60-5
001649 48-17 001812 3-17 001992 32A-8 007609 48-21
001650 30-37 001812 5-11 001992 46-22 007613 47-9
001650 39-21 001812 12-2 001992 50-16 ~007614 47-10
001661 4-12 001812 13-42 003042 ZlA-42 007628 32-8
001681 14-42 001812 20-19 003042 56-15 007633 44-22
001684 24-8 001812 23C-43 003042 84-3 007641 58-21
001689 87-31 001812 25-31 003578 11-18 007647 58-25
001690 66-5 001812 36-24 003578 llA-4 *007648 58-29
001690 70-24 001812 36A-16 003578 36-13 *007650 59-26
001691 54-28 001812 40-32 003586 43-4 007651 58-16
001693 72-37 001812 88-43 003850 61-15 007653 10-10
001694 19-48 001818 30-8 004074 11-12 007661 1-14
001696 18-27 001818 37-7 004074 llA-11 007662 14A-12
001696 87-26 001818 49-29 004256 12-4 *007663 14A-15
001702 12-3 001821 32-15 004256 34-11 *007664 47-11
001702 13-43 001821 37-14 005071 38-9 007668 lo-16
001702 32A-15 001821 48-7 005071 54-24 007672 67-11
001702 50-4 001824 51-24 005311 28-55 007672 68-2
001706 18-2 001825 40-25 005620 46-8 007672 68A-16
001706 35-39 001825 87-24 005620 79-12 007684 lo-28
001706 41-19 001840 32-14 006675 5-15 007689 1-19
001706 65-26 001840 48-12 006675 71-25 007694 5-22
001706 68-18 001840 81-5 006675 88A-38 *007696 62-5
001721 19-39 001845 40-41 006776 14A-45 007697 62-6
001721 29-44 001845 48-2 006801 64-18 007699 62-11
001722 54-21 001845 65-17 006917 6-11 007727 80-17
001725 31A-26 001845 90-14 006917 8-31 007729 48-18
001729 12-12 001847 45-5 006917 24-24 007731 47-6
001729 19-43 001847 54-17 006917 87-13 007743 54-3
001729 27-14 001854 72-22 006987 56-41 007745 36-12
001730 34-20 001884 2-7 007076 79-16 007751 62-28
001731 79-13 001920 57-4 007236 63-26 007762 47-13
001740 35-43 001920 85-6 007533 66-25 *007763 47-19
001740 37-8 001936 57-16 *007534 66-28 007764 47-3
001740 49-30 001956 19-2 007547 13-40 007766 43-33
001742 14A-38 001956 60-3 007549 19-15 007767 43-31
001747 9-3 001956 83-20 *007554 238-8 007809 1-14
001747 42-52 001975 29-31 007557 22-10 007852 13-17
001750 11-11 001976 22-12 007559 22-15 007856 llA-17
001750 llA-10 001978 11-28 007563 60-11 007859 lo-16
001750 61-26 001978 23-2 007565 23A-12 007862 l-10
001755 58-18 001978 23A-22 007567 23-18 007866 40-21
001755 61-9 001978 23B-5 007567 23-20 007867 40-15
001755 74-13 001978 62-29 007568 13-13 007870 40-16
001755 85-22 001978 85-10 007569 13-17 007875 40-40
001763 65-13 001980 14-16 007570 13-20 007887 39-17
001766 23C-47 001980 23-3 007575 35-2 007888 39-1
001771 001980 007575 36-2 40-4
001772 Fxi 001980 :;k253 007575 51-3 E::~; 39-14
001772 lli-8 001980 50-19 007575 82-16 007893 40-27
001772 25-4 001980 66-23 007576 13-21 007932 25-30
21
Part Fig.6 Part Fig.& Part Fig.6 Part Fig.6
007937 53-5 010364 5-24 011431 66-2 012440 30-16
007966 1 lA-1 010372 32-30 011432 66-3 012443 30-14
007980 32A-25 010378 7-5 011506 64-3 012444 28-5
007982 80-8 010379 7-5 011507 64-10 012449 25-20
007984 47-8 010388 7-11 011518 64-2 1 012450 25-5
007986 47-7 010389 7-15 011948 38-12 012457 18-23
007988 32A-2 1 010402 8-25 012095 14-27 012461 68-28
008009 40-29 010405 7-13 012141 10-2 012465 68-23
008024 12-14 010411 7-l 012141 15-14 012467 68-27
008024 36-26 010423 012145 18-26 012468 68-30
008026 13-20 011010 ii_“3 012146 18-24 012475 67-18
008029 69-10 011011 40-10 012147 28-10 012476 67-7
008038 l-17 011012 40-6 012150 29-30 012477 67-14
008145 4-27 011013 40-7 012151 29-26 012478 61-6
008150 75-20 011019 27-3 012155 27-9 012478 67-12
008152 75-18 011019 39-28 012161 43-15 012479 59-40
008154 75-19 011024 39-18 012163 43-6 012479 67-6
008156 4-10 011025 39-10 012168 29-35 012482 68-10
008160 75-11 011051 66-10 012170 29-34 012489 68-13
008218 40-20 011052 66-9 012178 29-21 012493 17-9
008220 40-24 011055 51-17 012207 42-51 012537 28-54
008221 39-29 011056 51-18 012228 29-24 012575 15-4
008222 40-31 011066 65-21 012235 30-36 012576 15-12
008224 40-5 011076 66-32 012241 35-22 012577 15-11
008227 40-l 011077 66-24 012242 43-12 012596 18-16
008289 63-23 011079 19-13 012243 26-12 012597 29-10
*008290 63-14 011132 28-41 012244 43-10 012599 29-11
009527 55-25 011133 28-42 012245 36-15 012654 26-2
009530 55-20 011140 43-16 012246 26-l 012655 26-3
009531 55-27 011154 29-20 012254 19-50 012659 28-3
009532 59-l 011176 34-6 *012260 14-23 012660 28-4
009535 59-4 011181 33-11 *012261 14-22 012661 25-17
009536 59-5 011194 35-10 012266 14-21 012673 10-15
009537 59-30 011195 35-9 012268 14-15 012687 30-22
009538 59-l 0 011199 25-14 012270 14-20 012697 16-14
009540 59-13 011203 15-16 012275 18-14 012705 44-12
009548 43-27 011205 17-2 012275 29-7 012716 31-31
009551 43-2 5 011206 17-17 012277 32-20 012722 14-35
009553 43-16 011207 17-23 012335 59-37 *012798 15-6
009554 43-24 011208 17-24 012337 59-39 012815 19-49
009558 44-23 011222 25-8 012338 59-38 012827 31-33
009559 44-28 011224 25-9 012341 16-13 012846 40-42
*009650 47-l 011229 51-19 012344 16-12 012848 41-5
009651 47-41 011252 30-27 012347 17-3 012913 63-28
009652 47-40 011253 28-28 012352 16-18 012925 40-34
009662 49-6 011256 30-5 012359 42-33 012926 42-34
009664 49-38 011259 30-29 012360 42-45 012927 42-29
009665 49-4 011262 28-32 *012367 16-6 012944 42-32
009667 44-5 011272 33-22 “012368 16-8 012945 42-49
*009670 47-l 011273 28-23 *012371 16-22 012947 40-39
009671 47-41 011274 30-6 *012375 15-21 012958 3-15
009751 31A -37 011371 11-29 012376 15-23 012959 3-14
009751 318-11 011371 12A-25 012378 17-6 012960 3-19
009757 3lA-34 011371 14A-11 012379 17-18 012961 3-2
009774 31A -1 011371 21-27 012380 17-15 012961 3-18
009777 3lA-27 011371 2lA-27 *012382 17-10 012962 3-l
009780 3lA-7 011371 52-11 *012383 17-12 012963 3-10
009788 3lA-6 011371 66-38 012386 16-17 012972 14-43
009791 318-12 011372 40-37 *012414 15-9 013007 68-34
009794 3lB-8 011396 45-21 012415 18-6 013007 68A-4
009796 3lA-29 011405 52-8 012418 15-1 013010 68-32
010142 56-37 011409 3-24 012422 11-5 013010 68A-2
010148 1 lA-2 011410 3-11 012422 llA-7 013262 42-16
010342 7-18 011411 3-5 012438 30-9 013264 42-18
‘11
Part Fig.& Part Fig.& Part Fig.6 Part Fig.&
013267 2-36 014203 70-39 014390 llA-15 014713 68-8
013287 63-20 014205 47-4 014390 13-24 014721 44-2
013386 11-2 014206 318-7 014390 23c-39 014727 25-3
013391 16-10 014206 32-5 014390 32-26 014727 37-26
013393 16-11 014206 47-47 014461 85-23 014727 38-15
013413 25-29 014207 22-6 014463 32A-2 3 014727 49-16
013421 11-l 014208 35-34 014465 28-31 014727 58-5
013434 68-35 014215 18-12 014465 30-l 1 014727 62-2 5
013434 68A-5 014215 21A-20 014504 14A-36 014741 19-53
013436 43-13 014215 26-7 014504 31A-18 014741 79-29
013494 36-37 014215 28-46 014504 42-15 014745 12A-14
013495 36-32 014215 31A-5 014504 47-26 014748 44-4
013509 18-21 014215 31A-30 014504 55-32 014750 22-24
013580 3-20 014215 35-37 014504 80-l 3 014751 65-6
013581 3-21 014215 68-l 6 014504 84-20 014754 34-3
013582 3-23 014216 34-2 014504 87-28 014757 88A-3 9
013820 10-14 014219 54-23 014504 88A-2 8 014760 25-7
013827 53-16 014219 79-l 4 014507 4-21 014761 79-18
013910 34-2 1 014225 l-25 014507 9-2 014761 81-14
013913 63-24 014233 64-19 014507 10-4 014770 26-8
013931 35-12 014234 12A-6 014507 15-17 014784 79-7
013932 35-14 014234 30-3 014507 23-38 014788 35-30
013933 35-7 014240 42-43 014507 23B-12 014793 14A-5
013947 66-22 014245 30-32 014510 83-l 014797 4-11
014108 23-l 6 014247 39-4 014511 38-28 014805 14-13
014108 23A-7 014247 81-19 014513 79-l 7 014805 14A-31
014108 46-43 014248 8-7 014514 88-33 014805 24-3
014110 29-19 014248 14A-26 014515 12-5 014807 l-36
014110 63-8 014248 22-21 014515 18-5 014807 17-8
014111 30-10 014248 31-17 014515 19-47 014807 27-l
014111 31-36 014248 49-40 014515 24-12 014807 35-33
014111 318-l 014248 57-10 014515 27-11 014807 36-46
014112 25-16 014248 63-27 014515 35-17 014807 42-36
014121 32-29 014248 85-l 5 014515 38-33 014807 55-31
014121 48-4 014249 72-19 014515 42-22 014807 62-13
014121 69-l 1 014250 31-32 014515 49-8 014807 63-1
014136 29-9 014250 31A-17 014515 55-30 014807 74-3
014143 87-31 014266 35-32 014516 31-38 014808 8-23
014149 54-46 014275 35-5 014516 318-4 014808 12-27
014151 21A-6 014276 40-36 014516 47-35 014808 12A-23
014151 25-11 014311 2-3 014517 32-7 014808 14-9
014151 28-4 9 014313 43-30 014517 48-22 014808 14-26
014151 43-32 014327 79-25 014518 10-17 014808 18-15
014157 22-9 014342 46-l 0 014523 13-30 014808 20-15
014157 43-22 014350 12-18 014523 23C-41 014808 25-13
014157 47-45 014350 12A-10 014529 54-34 014808 29-8
014158 18-19 014350 28-39 014570 43-35 014808 35-35
014158 56-20 014350 36A-22 014576 80-19 014808 36A-10
014158 59-19 014350 41-17 014605 14-5 014808 37-1
014164 80-14 014359 70-37 014605 14A-23 014808 37-4
014165 47-2 014369 59-8 014606 36-22 014808 39-36
014169 5-4 014369 61-14 014608 79-20 014808 47-5
014169 9-10 014369 65-33 014618 29-25 014808 49-32
014170 5-5 014372 10-19 014639 85-26 014808 50-l
014171 l-39 014372 11-22 014646 20-8 014808 54-15
014171 45-23 014372 llA-19 014646 21-31 014808 61-18
014172 32-16 014372 12A-11 014646 21A-31 014808 61-20
014172 48-6 014372 238-3 014653 45-19 014808 62-10
014173 32-13 014372 33-19 014688 21A-13 014808 70-19
014173 48-10 014372 36A-31 014703 5-17 014808 71-21
49-7 59-42 014703 82-24
00:44::: 68-7 cXf 60-18 014703 E1 KEE 23C-26
014180 19-10 014380 25-6 014712 62-16 014810 29-42
014192 44-l 014390 11-25 014712 86-10 014810 53-13
21s
Part Fig.h Part Fig.& Part Fig.6 Part Fig.6
014811 3-13 016376 83-3 016528 88-19 017481 36A 43
014811 41-9 016378 62-31 016533 88-20 *017484 46-;6
014811 59-7 016380 46-20 016534 88A-27 017485 46-11
014811 61-17 016381 80-l 016535 88A-7 017487 46-11
014811 69-35 “016384 79-l 016536 87-14 017528 2-19
014811 70-3 016385 79-2 016541 38-6 017537 2-5
014811 71-5 016387 79-3 016542 79-24
014812 70-2 7 016389 90-l 016543 88-31 017539
017541 I:‘6
014812 73-29 016390 90-3 016546 89-l 5 017542 65-18
014812 74- 7 016391 81-25 016547 90-15 017542 90-13
014819 23- 7 016393 81-15 016558 23C-44 017545 65-l
014819 23A-1 016396 81-24 016572 58-8 017578 37-23
014837 3-4 016397 81-9 016572 88-22 017582 83-12
014844 54-20 016398 81-12 016574 21-38 017589 70-12
014902 14-24 016399 84-9 016574 37-21 017594 66-36
014902 19-26 016401 90-22 016574 54-18 017595 66-35
014902 21A-15 016402 90-23 016574 83-13 017605 2-15
014902 41-11 016405 90-21 016584 88-41 017611 21A-8
014902 46-21 016409 84-15 016585 89-9 017613 21A-11
014902 54-45 *016410 84-19 016588 89-12 017615 21A-12
014909 56-16 *016411 84-l 7 016690 80-5 017616 21A-5
014910 22-12 016412 84-24 016691 80-7 017618 21A-3
014910 22-14 *016414 84-23 016695 89-18 017619 23B-1
014912 23-10 016416 85-l 016739 38-18 *017620 238-6
014912 23A-5 016418 85-5 016741 38-11 017622 219-g
014921 7-16 016421 82-23 016749 87-l 017623 21A-7
014921 20-21 016424 82-30 016783 33-13 017626 23A-18
014921 22-14 016429 79-28 016895 4-l 017627 37-5
014921 44-27 016430 82-20 016896 4-35 017630 21-21
014921 52-2 016431 82-18 016897 67-13 017630 21A-21
014972 32-21 016437 90-11 016897 68-31 017633 19-24
014972 45-14 016438 90-l 0 016897 68A-1 017636 21A-32
014973 17-11 016441 83-21 016898 68-36 017639 19-54
015034 52-12 016445 89-7 016898 68A-6 017640 19-55
015213 21A-4 016446 89-8 016916 38-4 017644 56-19
015490 8-20 016450 86-3 016918 71-24 017645 56-22
016060 66-l 3 016450 88-40 016921 42-2 017647 56-28
016158 48-l 6 016452 86-8 016921 85-20 017676 5-l
016197 7-21 016458 86-22 016933 83-14 017677 5-23
016204 51-20 016459 64-l 016937 19-32 017682 66-l
016205 51-2 016461 86-5 016941 36A-34 017693 21A-35
016206 36-5 016462 86-4 016942 36A-36 017702 21-25
016206 36A-11 016466 86-6 017017 89-14 017702 21A-25
016207 36-6 016466 88-36 017018 2-12 017704 12A-24
016208 89-4 016469 88-23 017018 89-13 017707 11-26
016209 89-3 016470 86-18 017090 017714 84-l
016210 51-2 016471 86-17 017090 E3 017715 56-14
016211 51-20 016472 83-19 017092 2-14 017715 84-2
016212 36-5 016477 85-25 017093 2-11 017722 65-24
016213 36-6 016478 88-31 017094 2-41 017734 36A-45
016271 14A-39 016481 85-9 017125 56-39 017735 23-4
016275 14A-9 016486 83-6 017133 59-21 017735 23A-24
016289 40-38 016489 83-9 017134 59-28 017735 32A-3
016298 64-15 016494 83-15 017137 91-5 017735 68-3
016299 82-15 016501 80-11 017140 2-26 017735 68A-13
016315 2-20 016502 81-20 *017150 57-18 017738 54-36
016318 8-2 016504 81-22 017151 56-47 017739 21-17
016327 66-12 016507 81-18 017151 57-13 017739 44-31
016363 81-29 016521 85-13 017159 38-19 017742 46-42
016365 88-39 016524 81-26 017163 4-29 017744 36A-39
016367 79-l 5 016525 88A-8 017172 2-42 017747 10-3
016368 79-19 016526 88A-10 017477 36A-44 017750 54-35
016374 79-l 1 016527 87-18 017478 46-37 017783 56-42
016376 79-9 016527 88A-18 017480 46-44 017788 21A-17
213
P@BJ#&&)
00 mm0 0
Part Fig .& Part Fig.& Part Fig.6 Part Fig.6

017793 12-22 021203 37-19 022805 72-14 025092 28-25
017797 4-29 021203 38-37 022810 76-2 025094 28-16
017799 4-14 021203 40-9 022812 77-3 025096 29-28
*017806 54-33 021203 42-14 022813 75-19 025097 28-15
017815 50-11 021203 61-24 022814 75-18 025098 29-1
*017816 50-12 021268 36-11 022816 73-32 025100 29-2
017819 36A-38 021369 85-14 022817 73-8 025101 29-16
017820 10-8 021457 236-19 022818 78-5 025103 25-l
017820 15-19 021563 28-40 022820 75-34 025104 25-10
017840 44-14 021563 55-33 022822 70-29 025106 25-15
017989 19-1 021563 87-27 022823 JO-31 025108 41-10
*017990 19-4 021781 42-20 022824 55-36 025114 41-12
017996 20-18 021861 12-19 022826 71-16 025116 39-8
017996 36-25 021861 12A-9 022830 88A-1 025120 27-5
018014 60-8 021861 35-38 022831 4-8 025120 39-30
018014 67-4 021861 41-18 022833 49-41 025122 42-3
018062 30-38 021861 68-17 022834 6-1 025123 65-11
018062 36A-25 021911 36-34 022836 70-28 025124 36-19
018151 7-8 021911 68-41 022837 45-32 025125 24-11
018314 021911 68A-8 022838 2-43 025126 24-17
018350 Fl3 022343 36A-35 022839 36-38 025127 24-15
018353 20-14 022621 5-12 022844 36-44 025127 38-36
018357 20-17 022621 88A-31 022845 36-45 025129 24-21
018358 20-6 022720 72-O 023042 90-10 025132 24-25
018360 20-5 022727 23C-30 023044 88A-40 025133 67-16
018362 20-7 022728 23C-16 025019 39-o 025134 56-13
018362 21-29 022729 23C-20 025019 40-O 025135 4-13
018362 21A-29 022731 23C-17 025020 72-O 025136 4-23
018364 20-l 022734 23C-42 025023 33-1 025137 4-22
018366 20-11 022736 23C-1 025024 72-O 025138 4-15
018366 21-23 022739 23C-4 025030 31-44 025139 4-20
018368 20-4 022740 23C-12 025032 31-9 025140 4-24
018383 20-11 022743 23c-9 025034 31-5 025141 4-3
018383 21A-16 022743 236-29 025036 31-25 025142 4-33
018383 21A-23 022744 23C-21 025038 31-28 025141 66-11
018402 59-32 022745 36-40 025043 31-37 025148 59-36
018405 43-29 022746 36-41 025044 31-22 025148 67-1
018469 43-3 022748 36-43 025046 31-19 025151 73-9
018571 69-2 022751 4-13 025047 31-18 025153 73-19
018575 43-18 022752 75-12 025049 31-42 025154 73-14
018577 43-19 022753 4-15 025056 16-1 025156 73-23
018580 43-2 022757 58-30 025056 17-l 025157 73-21
018593 31A -19 022758 58-33 025057 17-19 025158 73-24
018594 31A-14 022759 58-25 025059 16-20 025160 71-18
018595 31A-13 022761 59-30 *025060 16-21 025161 72-9
018596 31A-16 022766 58-12 025062 17-22 025163 72-12
018599 31A-22 022767 58-15 025064 17-16 025166 74-4
018602 31A-9 022770 59-43 025065 17-20 025168 74-16
018603 31A-36 022771 59-17 025067 16-4 025171 24-32
018604 3lA-35 022772 58-35 *025068 16-5 025171 75-14
018623 31A-33 022773 58-34 025070 17-5 025173 75-16
018624 31A-38 022777 4-27 025071 16-26 025114 72-31
020138 43-17 022778 58-16 025073 43-24 025115
020379 36A-20 022779 58-21 025074 43-27 025181 z4
021150 36-11 022781 23C-46 025075 28-1 025184 2-2
021150 42-9 022783 25-l 025075 29-o 025187 2-11
021203 14A-34 022783 32A-20 025075 30-O 025188 2-38
021203 19-18 022788 59-16 025076 30-18 025191 45-15
021203 23-46 022196 4-24 025079 28-50 025192 67-19
021203 236-21 022797 a-6 025082 28-47 025194 69-33
021203 24-2 022800 76-7 025084 28-51 025195 67-15
021203 29-14 022801 78-4 025086 30-l 025195
021203 31A-25 022802 38-39 025088 28-36 025197 w
021203 34-4 022803 73-9 025090 28-43 025198 19-41
-2 1
P@fJ$&Q
00 mm
0 0
Part Fig.6 Part Fig.& Fart Fig.6 Part Fig.6

025200 34-10 025322 78-4 025446 33-3 040868 15-18
025201 34-19 025323 78-5 025447 33-4 041291 40-17
025203 34-17 025324 78-6 025448 73-10 041291 53-15
025204 34-18 025329 70-25 025450 72-35 041750 80-6
025206 34-15 025332 74-15 025453 75-30 041774 30-34
025207 34-l 025337 74-2 025455 75-32 041774 49-35
025208 34-7 025341 42-24 025456 73-9 041776 22-l
025210 33-24 025343 18-1 025459 2-39 041776 58-10
025216 33-15 025344 41-20 025468 31-6 041776 79-4
025220 33-14 025345 27-8 025470 8-15 041777 18-10
025224 33-21 025346 14-40 025470 64-16 041777 37-17
025225 33-17 025347 19-42 025472 8-13 041777 53-18
025226 33-8 025348 18-20 025474 8-32 041777 56-11
025228 33-10 025350 65-16 025475 2-16 041821 69-5
025229 33-7 025353 69-7 025476 73-19 042150 28-9
025231 33-16 025354 69-8 025478 76-2 043097 14-12
025233 33-6 025355 65-28 025479 76-l 043097 14A-32
025234 33-26 025357 4-4 025480 74-8 043097 24-4
025237 38-7 025358 025481 73-30 050435 58-11
025238 14-29 025359 t-:9 025481 74-6 050621 63-10
025240 15-3 025361 73-16 025496 69-6 050621 82-26
*025241 15-5 025362 89-18 025499 77-6 052218 26-16
025243 25-26 025363 4-8 025512 74-25 053184 31-41
025244 10-10 025364 2-39 025522 2-l 054147 56-40
025247 11-20 025365 75-4 025525 4-6 054350 83-7
025249 14-1 025366 88A-35 025527 70-28 054409 19-19
025254 87-7 025367 75-12 025528 2-32 054479 69-l
025255 87-8 025370 4-7 025529 76-6 *055535 23B-10
025256 87-30 025372 72-30 025530 74-12 057507 14A-24
025257 87-10 025373 25-21 025531 74-11 058552 62-l
025258 19-24 025375 24-35 025532 74-10 059018 35-41
025260 19-1 025377 7-l 025536 2-37 061452 38-26
*025261 19-5 025378 7-11 025538 75-23 061452 63-2
025264 23-35 025380 7-13 025539 75-23 062704 40-18
025268 37-13 025381 11-7 025543 68-19 063087 12A-15
025270 23-34 025382 11-8 025544 77-5 063117 30-15
025273 24-33 025384 6-l 025545 77-4 063206 12A-12
025282 72-33 025386 6-15 025658 89-18 063206 28-8
025286 75-2 025387 6-4 025659 89-18 064059 lo-24
025289 72-28 025389 70-20 025670 75-18 064112 62-7
025291 72-23 025390 70-23 025671 75-34 064189 11-10
025292 72-16 025391 71-15 025676 75-34 064189 llA-12
025293 72-8 025392 70-14 027291 32A-22 064234 36A-18
025295 73-11 025395 87-33 028797 25-32 064234 62-8
025295 75-25 025396 76-8 031307 12-1 064589 36A-2
025296 75-10 025401 65-31 031307 28-29 064590 56-24
025298 75-33 025406 9-7 031748 39-34 064673 24-38
025300 70-31 025407 9-17 032868 064673 38-35
025301 71-17 025408 9-13 032868 :I266 064673 49-34
025302 70-30 025409 9-14 032868 28-33 064673 71-22
025303 46-40 025410 72-8 039642 14-31 064673 88A-41
025303 71-16 025411 8-18 039642 21-19 064674 42-8
025305 70-29 025412 9-l 039642 23-5 064764 9-16
025308 74-17 025413 039642 23A-25 065329 70-6
025309 74-23 025414 ;:"5 039642 32A-2 066238 5-9
025310 76-2 025417 4-27 039642 44-32 066763 41-13
025311 76-7 025419 76-7 039642 54-37 070125 14A-25
025312 77-1 025420 77-3 039642 66-40 *070226 47-15
025314 77-2 025421 74-17 039642 68-5 071556 58-12
025315 76-5 025423 8-24 039642 68A-15 071561 49-26
025316 025425 73-3 040782 14-10 14A-22
025317 ::-: 025431 82-13 040782 EZ
025319 7812 025441 73-a 040782 igAG 071570 biAi231
025321 78-3 025445 68-26 040868 1016 071576 57-20
215
Part Fig.& Part Fig.& Part Fig.& Part Fig.&
58-9 072442 60-26 *072/gc 55-I
071576 66-18 072220
071576 84-12 072230 55-16 072442 61-7 072795 2-13
071594 238-2 072233 55-12 072471 56-6 072796 5-19
071596 36A-14 072239 55-17 072472 56-7 072821 67-17
071606 36A-15 072243 55-11 072478 52-19 072821 69-14
071610 36A-23 *072245 60-12 072481 52-18 072822 69-29
071611 36A-6 072254 61-2 072482 52-21 072826 69-32
*071625 46-23 072254 67-5 072482 54-30 072838 69-13
*071648 238-9 072256 68A-12 072484 53-19 072840 69-12
*071649 238-7 072257 68A-11 072488 54-27 072852 69-16
072024 66-16 072258 6-3 072491 54-29 072854 69-20
072029 66-4 072260 69-18 072504 56-12 072855 69-25
072035 57-19 072261 69-15 072511 1-15 072862 42-46
072035 84-11 072262 69-17 072511 37-16 072919 69-22
072036 84-14 072264 69-19 072511 52-16 072920 69-23
072037 66-17 072265 69-24 072512 56-10 073004 13-37
072040 37-27 072271 23-11 072534 55-21 073011 13-1
*072041 57-17 072271 23A-3 072544 5-10 *07301i 13-4
*072044 66-27 072272 23-9 072544 56-23 *073014 13-3
072051 8-8 072272 23A-4 072561 53-3 073029 23-47
072052 11-30 072277 23A-28 *072574 57-6 073029 23B-19
072052 12A-26 072278 23A-27 072575 57-8 073043 19-36
072052 14A-10 072292 l-20 072576 56-29 073091 19-14
072052 21-26 072314 62-4 072579 56-31 073094 19-12
072052 21A-26 072325 62-17 072580 56-27 073097 23-23
072052 52-10 072327 62-36 072586 56-25 073097 23A-16
072052 66-37 072328 62-14 072589 56-8 073098 23-22
072055 51-11 072333 46-27 072599 57-11 073098 23A-15
072056 51-12 072333 62-26 *072605 46-18 073107 19-28
072063 66-19 072336 46-20 072610 53-7 073107 36A-3
072064 66-30 *072337 46-25 072620 20-10 073108 13-52
072069 66-15 *072338 46-24 072620 21-40 *07311c 13-46
072070 66-14 072347 63-9 072620 21A-40 073120 19-11
072077 57-21 072349 36-4 072620 56-44 073123 19-9
072099 59-16 072354 49-25 072621 56-32 073140 36-9
072106 59-17 072357 37-9 072625 19-23 073152 13-39
072124 58-24 072357 49-27 072625 28-26 073193 13-23
072124 58-28 072358 37-10 072626 53-14 073234 13-57
*072125 58-27 072358 49-28 072628 62-22 *073246 14A-14
072126 58-6 072362 49-17 072629 62-23 073248 14-4
072129 37-32 072366 47-18 *072636 57-5 073248 14A-19
*072134 59-23 072367 37-29 072655 45-22 073250 14-3
*072136 59-25 072367 47-17 072704 61-16 073250 14~-20
072143 59-29 072367 49-20 *072710 60-2 073252 14A-18
072143 67-9 072369 37-31 072712 60-7 073308 10-5
072154 58-l 072370 37-13 *072717 60-14 073316 23-19
072161 69-21 072373 37-15 *072720 60-16 073316 23A-13
"072169 50-15 072378 49-39 072734 61-28 073316 23C-2
072175 54-7 072382 54-19 072741 67-8 073326 31-15
072175 55-9 072383 54-25 072741 68-6 073327 23-17
072176 54-6 072386 37-22 072741 68A-10 073327 23A-11
072176 55-8 072394 32-10 072748 60-19 073330 36-3
072177 55-5 072398 36-15 072756 9-4 073333 54-26
072181 45-30 072399 32-19 072757 5-2 073336 23-30
072181 46-5 072412 61-21 072757 9-8 073338 13-12
072184 62-20 072412 71-20 072763 2-8 073338 23-14
072186 54-16 072413 49-23 072763 9-11 073339 13-44
072189 55-14 072416 32-17 072765 5-7 073373 56-2
072197 l-28 072424 36-16 072767 5-6 073381 56-4
072199 54-12 072427 54-22 072774 5-16 073385 l-22
072201 54-14 *072441 47-16 072775 5-21 073394 l-l
072205 54-43 072442 37-25 072784 5-20 073417 69-31
072207 54-42 072442 49-14 *072787 46-14 073443 23A-17
072210 55-15 072442 55-35 *072790 54-5 073444 23-25
216
Part Fig.6 Part Fig.& Part Fig.& Part Fig.6
073445 23A-6 076124 23-15 078712 47-39 080505 llA-13
073446 23-24 076142 61-5 078714 44-17 080522 45-10
073447 23-26 076142 67-20 078728 48-9 080524 11-4
073448 23-27 076142 68A-19 *07a729 47-14 080524 llA-6
073459 63-5 076194 13-18 078744 47-25 080536 10-7
073463 l-38 076218 22-26 078744 54-10 080539 10-21
073464 l-40 076386 23-44 079613 75-28 080541 10-22
073467 1-21 076386 23B-17 079764 42-26 080564 80-12
073469 l-23 076481 23-8 079764 71-1 080581 10-14
073472 l-24 076481 23A-2 079905 22-13 080583 10-9
073473 66-6 076605 54-38 079912 19-3 080583 15-15
073478 60-4 076684 63-33 080032 52-20 080591 11-21
073482 22-7 *076727 19-6 080144 56-21 080591 llA-18
073486 60-25 076734 21-39 080153 54-31 080599 11-24
073487 39-27 076734 21A-39 080184 53-2 080599 llA-16
073487 59-41 076835 8-21 080191 45-12 080621 48-8
073487 67-2 076856 44-26 080192 62-35 080630 21-35
073493 61-22 076869 8-10 080238 31A-32 080634 21-37
073494 61-27 076882 42-11 080241 25-19 080634 21A-37
073496 61-12 076882 60-22 080247 45-18 080694 13-27
073497 61-10 076887 1-37 080263 13-32 080694 23C-32
073498 61-19 076887 55-19 080263 23C-38 080695 13-34
073512 20-16 076889 l-34 080295 13-8 080695 23C-36
073524 12-20 076890 1-31 *080297 13-47 080698 13-31
073540 lo-27 076893 l-18 080298 13-48 080698 23C-40
073542 lo-26 076894 60-24 080299 13-49 080699 13-33
073544 8-22 076897 7-9 *080317 13-51 080699 23C-37
073551 32A-11 076898 8-3 488334 57-l 080715 32-24
073551 50-13 077117 63-22 *080336 57-15 080716 32-23
073710 22-11 077236 63-21 080337 57-7 080717 32-25
073712 59-20 077301 32A-19 080349 19-38 080718 44-21
073894 22-5 077301 50-a 080376 45-25 080719 43-21
074313 39-11 077459 19-29 080376 46-3 080814 31-39
074314 39-20 077822 29-40 080378 46-9 080814 318-5
074323 36-21 077836 31A-21 080396 52-l 080814 47-36
074324 36-7 077836 32A-18 "080397 52-4 080820 318-6
074324 36A-12 077836 50-6 *080400 52-3 080820 32-6
0 74 3175 33-12 077866 63-19 080402 52-14 080839 3-9
074375 36-14 077939 31-2 080404 52-5 080839 39-16
074400 58-14 078301 58-15 080407 53-12 080910 31-40
074717 8-16 *078337 32A-9 080408 53-9 080910 318-13
075039 12-11 078338 32A-4 080409 52-7 080911 32-11
075058 12-6 078346 32-32 080410 53-10 080952 37-5
075074 35-26 078363 38-27 080411 59-31 080956 32-27
075074 42-23 078363 63-4 *080414 46-12 080972 32-2
075443 70-33 078364 63-18 080433 22-16 080979 llA-20
075537 36A-24 078367 63-16 080447 32-28 081037 48-20
075643 12-21 078368 63-3 080447 48-11 081104 47-22
075644 12-26 X078445 46-23 080448 32A-7 081106 47-30
075644 36A-1 078520 44-9 080448 50-17 081107 82-25
075645 12-7 078520 47-37 080449 32A-10 081152 52-9
075836 56-34 078524 44-15 080449 50-18 081156 37-6
075883 l-11 078527 44-6 080452 32A-16 081321 42-17
075884 l-8 078541 44-25 080452 50-7 081515 90-2
075885 l-9 078542 44-24 080473 22-17 081516 90-4
075887 l-3 078551 44-4 080481 68-33 081527 81-4
075888 1-6 078552 43-28 080481 68A-3 081528 81-3
075890 l-2 078556 43-23 080486 48-13 081553 81-28
075931 22-19 078626 12A-21 080495 48-3 081553 85-4
075987 22-3 078628 12A-3 080496 48-l 081553 86-7
075991 22-22 078638 12A-7 080498 48-15 081553 88-35
*076084 46-17 078646 12A-18 080504 lo-18 081567 85-28
076100 47-42 078660 12A-22 080505 10-20 081575 85-12
076122 31-35 078669 -12A-8 080505 11-23 081597 83-10
17
P mm
Part Fig.6 Part Fig.& Part Fig.6 Part Fig.6
081604 85-16 087814 2-8 100647 44-34 101151 24-27
*081607 57-3 087830 2-19 100648 45-6 101170 65-15
081609 85-8 091045 42-50 100649 44-33 101195 3-8
081623 81-6 091151 39-33 100653 12A-5 101203 65-7
081720 84-21 091151 42- 50 100653 31B-2 101234 42-40
081762 80-18 100110 42-27 100657 101281 84-22
081764 80-15 100110 50-22 100657 &i-28 101291 43-14
081789 83-2 100119 66-29 100666 64-6 101330 35-8
081833 85-27 100122 29-l 7 100678 59-6 101332 19-16
081836 81-7 100130 47-21 100683 73-28 101333 23-36
082050 11-9 100131 32-31 100683 74-24 101333 45-16
082050 llA-9 100134 41-7 100701 58-l 3 101333 46-22
082057 32-3 100134 70-2 100704 39-15 101334 39-32
082103 44-13 100134 71-8 100731 82-14 101336 42-38
082128 47-46 100137 71-23 100738 43-8 101374 72-l 1
082129 48-18 100137 88A-36 100740 38-16 101398 73-17
082131 47-29 100141 32-l 100741 23A-19 101494 2-21
082135 47-33 100167 318-10 100813 31-24 101494 8-l
082172 44-20 100176 32-22 100814 12A-20 101494 82-12
082421 124-l 3 100177 1-12 100815 12A-4 101554 28-45
083168 73-18 100185 45-13 100815 30-2 101558 14-39
083316 45-3 100188 3-6 100820 12-8 101570 4-18
083317 45-8 100201 31B-9 100827 36A-40 101611 60-23
083388 73-18 100216 33-23 100835 74-14 101612 27-17
083392 65-3 100228 4-16 100857 32-12 101757 31-27
083393 65-8 100228 70-13 100860 29-43 101758 4-25
083394 65-14 100246 31-23 100863 21A-28 101760 9-12
083412 73-2 100296 48-19 100871 15-2 101773 27-10
083594 23C-14 100335 3-7 100871 90-9 101869 65-12
083648 2-40 100347 70-26 100878 15-22 101870 1 lA-23
083748 75-22 100347 78-8 100880 28-19 101876 32A-6
084059 34-5 100366 88A-26 100884 28-56 101887 69-3
084077 35-4 100367 29-41 100891 37-11 101899 90-6
084117 31-34 100369 12-9 100891 49-31 101900 90-8
084126 2-35 100388 63-31 100892 16-15 101901 90-5
084143 41-4 100392 43-26 100939 73-17 101913 65-19
084225 31-13 100398 63-32 100940 69-27 101921 91-2
084238 35-18 100400 14-2 100957 35-23 101922 91-4
084239 35-36 100442 41-3 100958 31-4 101938 82-35
084244 35-28 100442 68-2 1 100960 70-l 1 101938 84-26
084248 60-10 100450 3-16 100960 82-29 101938 86-13
084279 26-11 100483 12-10 100966 57-2 101941 89-6
084289 36-35 100483 59-33 100969 23-42 101942 89-5
084291 36-36 100485 2-25 100969 238-16 101943 90-12
084353 24-28 100490 26-13 100969 23C-48 101944 6-2
084407 36A-37 100490 38-22 100969 82-33 101944 87-9
084412 13-9 100507 35-42 100969 88-37 101944 88-9
084413 13-5 100508 43-20 100976 80-4 101944 88A-9
084418 12-25 100521 82-32 101001 25-12 101947 81-21
084421 19-21 100523 87-34 101005 63-29 101961 87-6
084422 19-20 100523 90-7 101007 28-2 101976 8-12
084461 33-20 100539 87-29 101020 28-13 101976 64-17
084462 33-18 100539 88A-29 101023 86-2 101978 73-31
084473 66-31 100554 15-7 101033 23A-29 101981 2-22
087266 66-14 100554 23-37 101051 13-50 101982 2-23
087496 13-41 100554 31-10 101051 30-31 101983 7-20
087702 89-9 100554 58-i 7 101051 32A-14 110002 71-29
087705 89-12 100576 19-34 101051 50-3 110002 a8A-33
087729 72-14 100579 1-13 101086 12-23 110035 74-21
087756 71-19 100582 34-14 101086 13-10 110035 75-3
087756 88A-30 100583 101112 72-15 110246 3-12
087808 2-8 100593 ii235 101144 2-7 111006 6-9
087809 2-34 100593 70-34 101144 89-10 111006 8-29
087811 2-34 100646 45-7 101145 89-11 111006 24-23
218
Part Fig.6 Part Fig.&’ Part Fig .& Part Fig .6
111006 25-39 111068 14A-16 150083 44-l 1 150089 89-l
111006 87-12 111068 23-45 150083 44-19 154078 14A-40
111011 7-20 111068 238-20 150083 45-l 7 154078 38-27
111011 72-27 111070 2-27 150083 46-2 154078 42-10
111033 24-16 111070 7-3 150083 49-2 181019 25-34
111033 38-23 111071 42-35 150083 52-13 181206 41-1
111033 49-3 111073 11-15 150083 54-47 190103 14-6
111033 55-34 111073 llA-24 150083 60-21 190103 14A-29
111033 72-10 111073 13-6 150083 61-11 190107 47-31
111033 73-15 lllQ73 43-5 150083 62-3 190110 54-9
111033 74-19 111073 51-13 _ 150083 64-9 190111 47-12
111033 75-l 111073 58-2 150083 65-27 190116 51-23
111034 8-14 111073 65-23 150083 79-10 19-O118 14-7
111034 9-15 111073 66-7 150083 81-1 190118 14A-28
111034 68-24 111073 68-l 150083 83-5’ 190129 65-20
111034 75-17 111073 68A-17 - 150083 88-24 190135 26-6
111035 55-l 0 111073 74-l 150083 88A-24 190135 47-23
111035 73-27 111073 90-20 150085 1-4 190137 31A-?
111035 87-16 111074 - llA-25 150085 I-i7 190148 37-2
111035 89-24 111074 12-24 150085 6-17 190149 19-52
111036 38-32 111074 13-11 150085 7-4 190149 23C-5
111036 51-10 111074 23C-15 150085 8-4 190149 29-38
111036 73-l 3 111074 46-7 150085 11-16 190149 47-34
111036 75-27 I 111074 58-7 150085 llA-26 190149 54-2
111051 20-3 111074 65-4 150085 12-16 190149 55-4
111051 24-l 8 111075 1-26 150085 12A-2 190157 81-8
111051 36-42 111076 13-54 150085 13-7 190179 45-9
111051 73-22 111077 12-15 150085 14A-7 190220 81-23
111051 75-29 111077 13-56 150085 19-8 190236 43-34
111052 16-16 111079 13-55 150085 23-29 190254 19-40
111052 17-21 111087 79-6 150085 23A-9 190254 22-23
111052 70-21 111089 11-14 150085 23C-11 190329 3_lA-15
111052 82-22 111089 51-22 150085 24-20 190329 56-43
111052 86-23 111089 66-20 150085 --29-29 190382 23-39
111052 88-30 111089 69-4 150085 32A-12 -190382 238-13
111053 19-56 111089 90-16 150085 36-13 190383 23-40
111053 42-41 1 Ll.091 65-4 150085 37-24 190383 23B-14
111053 65-25 111098 38-30 150085 39-7 190387 13-19~
111054 4-32 111099 36-30 150085 49-21 190394 14-38
111054 8-11 112652 -4-30 150085 50-9 190398 69-28
111054 36-10 122502 59-35 . 150085 51-14 190483 38-17
111054 49-l 0 130033 15-8 150085 52-6 190555 6-12
111054 79-23 130033 18-l 7 150085 54-13 190555 7-17
111054 82-28 130033 59-15 15~0085 55-22 190555 - 8-28_
111054 83-4 140023 39-9 150085 56-26 190555 24-26
111055 l-32 141573 50-14 150085 60-27 190555 25-36
111055 8-33 149319 83-11 150085 61-4 190555 72-24
111055 22-18 149329 33-9 150085 63-11 190555 87-15
111055 42-25 149344 28-53 150085 65-2 190557 7-18
111055 44-l 8 149344 58-26 150085 66-8 190557 25-38
111055 45-20 149385 57-14 150085 91-7 190601 40-43
111055 46-l 150050 42-31 150087 35-16 190631 36A-9
111055 60-20 150080 81-17 150087 39-24 190699 91-3
111055 62-2 150081 4-34 150087 66-34 190713 19-46
111055 79-8 150081 38-31 150087 69-9 190713 -24-13
111055 88-2 1 150081 51-a 150087 90-l 7 190713 38-34
111057 44-10 150081 72-l 7 150088 62-19 190713 49-9
111058 150081 87-17 150089 32--33 190713 55-29
111058 &918 150081 89-23 150089 36-33 190731 7-17
111059 63-30 150083 6-16 150089 38-29 190768 37-3
111060 8-19 150083 8-17 150089 48-5 190768 50-2
111060 81-2 150083 19-31 150089 53-8 368-5
111060 88-26 150083 40-l-2 150089 54-8 :“9w
111060 88A-26 150083 42-4 150089 62-38 191173 E:Y

9870 Parts

Uploaded by

Copyright:

Available Formats

9870 Parts

Uploaded by

Document Information

Original Title

Copyright

Available Formats

Share this document

Share or Embed Document

Sharing Options

Did you find this document useful?

Is this content inappropriate?

Copyright:

Available Formats

9870 Parts

Uploaded by

Copyright:

Available Formats

WARNING:

THIS EQUIPMENT MUST BE CONNECTED TO A PROPERLY GROUNDED THREE (3)

THE CIRCUIT TO WHICH THIS EQUIPMENT IS CONNECTED MUST BE CURRENT

THIS EQUIPMENT MUST NOT BE OPERATED WITH SAFETY COVERS AND/OR

WHEN SERVICING THIS EQUIPMENT WITH COVERS REMOVED. EXPOSED

NOTE TO USERS OF CATALOG:

The part numbers for all difference in

PARTS IDENTIFICATION AND ORDERING INSTRUCTIONS

1. (*I Part of an assembly and not sold separately.

1. O.S. = Operator Side

Figure Description Card Location

68A Air and Vacuum Valve Assembly (M-9870) O-66 B7

68 Air, Vacuum and Shuttle Valves O-66 B5

14 Aquamatic Control Shaft O-64 Cl3

14A Aquamatic Control Shaft (M-9870) O-64 Dl

12 Aquamatic Lockout Shaft O-64 c7

12A Aquamatic Lockout Shaft (M-9870) O-64 c9

10 Aquamatic - Part I O-64 Cl

11 Aquamatic - Part II O-64 c3

11A Aquamatic - Part II (M-9870) O-64 c5

82 Back Jogger Mechanism - Part I O-66 D7

83 Back Jogger Mechanism - Part II O-66 D9

88 Back Stop Chain Delivery O-66 E5

43 Blanket Cylinder - Part I O-65 Dl

44 Blanket Cylinder - Part II O-65 D3

39 Blanket Washer - Part I O-65 c7

40 Blanket Washer - Part II O-65 c9

42 Blanket Washer Pump O-65 Cl3

41 Blanket Washer Soleniod O-65 Cl1

54 Buckle Adjusting and Levers O-65 E9

46 Cam Shaft Assembly O-65 D7

69 Compressor Assembly O-66 89

72 Control Box and Cover D-66 Cl

73 Control Box Divider Assembly O-66 c3

76 Control Box Harnesses - Part I O-66 c9

Figure Description Card Location

77 Control Box Harnesses - Part II O-66 Cl1

75 Control Box P.C. Boards O-66 c7

74 Control Box Relay Bracket O-66 c5

78 Control Box Ribbon Cables O-66 Cl3

4 Control Panel O-64 B3

2 Cover Assemblies O-64 Al3

89 Cover and Frames - Chain Delivery O-66 E9

62 Delivery Roller and Stripper O-65 Fll

90 Dolly and Frame Assemblies O-66 El1

85 Dolly Raise Control O-66 D13

84 Dolly Raise Shaft Assembly O-66 Dll

45 Drive Shaft Assembly O-65 D5

38 Emergency Stop and Doubles Switches O-65 c5

16 Etcher Assembly - Part I O-64 D5

17 Etcher Assembly - Part II O-64 D7

15 Etcher Bottle and Actuator Shaft O-64 D3

18 Etcher Soleniod and Motor O-64 D9

56 Feed Mechanism and Power Link O-65 El3

55 Feed Solenoid and link O-65 El1

66 Feed Table and Paper Guides O-66 Bl

57 Feed Table Raising Mechanism O-65 Fl

53 Feed Table Release Lever O-65 E7

65 Frame - Base and Drive Motor O-66 Al3