TTNFC EN 00 - Circuit

DIAGRAMS
― CONTENTS ―
Electrical Connection Diagram (1/2) ......................................................................................... 2

Electrical Connection Diagram (2/2) ......................................................................................... 3
Fuses and Relays .................................................................................................................... 4
Front Chassis Wiring Diagram ................................................................................................. 5
Rear Chassis Wiring Diagram (1/2) .......................................................................................... 6
Rear Chassis Wiring Diagram (2/2) .......................................................................................... 7
Rear Chassis Wiring Diagram (Transmission) .......................................................................... 8
Front Console Wiring Diagram (1/2) ......................................................................................... 9
Front Console Wiring Diagram (2/2) ........................................................................................10
Floor Wiring Diagram (Rear Console) (1/5) ............................................................................. 11
Floor Wiring Diagram (Rear Console) (2/5) .............................................................................12
Floor Wiring Diagram (Side Console 1) ................................................................................... 16
Floor Wiring Diagram (Side Console 2) ................................................................................... 17
A/C Control Panel Harness .....................................................................................................17
Hydraulic Circuit Diagram .......................................................................................................18
ZW310-5A Electrical Connection Diagram (1/2) J-A
Starter switch E
ICF (C1,C2)
(R)(011)
B M ACC G1 G2 ST Monitor (1-1) (Battery) FA8 C-1 A-19
Preheat GSM(16,17), GPS(A-2) C-2 A-29
OFF Load dump1,2 relay E (Key SW M) FA13
(Y)(021)
C-7 A-30
B (912-c) (GW)(707)
ACC [W] FA8 (011)(R) Alternator (L) C-8 C-14
ON Battery Power supply (main) E05 E01
10A C-15
Start disconnect E06 E02 C-9
SW (opt) B
(921) 12V (920) 12V (000)
(912-b)[W] (912)[W] (911)[R] 100 [R] 100 [R] 100 100 BR
70A (965-b)
Battery Power supply R FA15 (065)RL
(P)(582)
+5V
F01 A-5
(proportional valve) 10A F04 A-7
(YG)(581)
TXD Y(021)
F02 (Key SW M) FA13
Secondary steering motor (opt) BR F05 A-6
(LR)(584)
RXD
F03 MPDr. A10 E
ES F06 (WB)(585)
100 (923)[R] 100 (P)(121) A-28 GND RS232C (011)(R) (457) (458)
M F25(+5V) E (RL)(583) (Battery) FA8 (P) (O)
C1 ECM2 relay
A-17 RTS
(WG)(594)
Load dump1 relay Throttle pedal (W)(351)
A-18 CTS
(PB)(134) A12
WY BW F solenoid valve A1 ECM1 relay
(011) (461) (462)
D14 (BW)(352)
(R) L Monitor BY RW A13 S1H
A10
(V) Monitor
FA8 B5 Pump output pressure sensor C-5
(2-17) (G)(125) (L)(353) L GB S1L (2-16)
(Battery) GB
C13
A15 R solenoid valve C-11
(471)(RW) (GB)(354)
Loading primary pilot pressure sensor A14 Load dump2 relay
(901-a) (021) (701) (Y)(128) S1H
(923) D28 (LW)(355) LW GB
W FA13 (Y) A03 1st solenoid valve
LY WB
(GW)(356)
S1L CAN1 B
G1 10A Lift arm raise pilot A02 S1S F
B
M pressure sensor (opt) (RL)(131)
C14 A08 (RL)(357) RG BY
2nd solenoid valve B (912-c) J
ACC C1
G2 (V)(122) A09 (BY)(358) E [W] FA10(013) A
ST Gr
(901) F16(-) RW(711)
18 29
(905) O (RW)(359) RW BY 10A G
YG Battery relay D06 A11 3rd solenoid valve 28 30 H
(BL)(360)
D07 A10 (912-c)
A1
FB12
(009)
Starter 39 C
10A
(961) [W] FA9 YB

FB1
5A
[R]15 [R]20 (R)(361) R BW (RW)(598) LW(713)

Starter motor E A04 4th solenoid valve B-9 A-20(RTS) 7 40 D
(922) (BR)(362) (YR)(597) 10A
(032) (001) B G (BrY)(137) A05 B-1 A-21(CTS) 8 50 E
WL GR
100 [R]
B G
100 Steering pressure switch (opt) F09 (Gr)(596) B S1H
C B-2 A-31 17 46
E A16
(RY)(321) Pump swash plate tilt
(906)
G J-A Radio
A17 (LY)(322) solenoid valve (Gr)(579)
37
S1L E INSITE
Y(021)
(W)(123) F26 A-20 A-9(TXD) 38 36
(907) Voltage Lift arm angle sensor (opt) (+5V) B16 (WB)(325) (Key SW M) FA13
LB (Y)(135) (YR)(577) C-4 S1H
(705) relay (704) D08 B15 (BR)(326)
Cooling fan solenoid valve A-19 (WAKE UP)
B6 YB RG C R(715)
48
S1L CAN1
Hydraulic fan circuit A-10
(Br)(578)
A-8(RXD) Remote throttle S1S
W(716)
Magnetic SW pressure sensor (opt) (Gy)(139)
A19
(YR)(327) Cooling fan solenoid valve (Key SW M) (Y)(021)
A-1 21
(902-a) D09
W Monitor (GY)(328) (reverse) (opt) FA13 A-10 B(717)
49 WR(566) WAIT TO START
FB11 (5A, Radio, Dome lamp) 12V,150mA (2-28) Parking brake pressure (low) sensor A18 (DG_IN1) 4
(RL)(127) (Battery) (R)(011)
WR(712) Monitor (1-21) Glow (1) lamp
A-2 Diagnostic SW 44
ICF(C8) D15 FA8
(902-b)
[W] FA4 (10A, Lighting switch) 1.5A Alternator(75A) Service brake
B22
B21 (GW)(707)
A-11 (BY)
(593)
ICF E INC RY(770)
GPS(A-3) primary pressure sensor Alternator (L) A-3 A-12 (M) 14
FA5 ((15A), Option battery) (799)WL (707)GW
(YB)(126)
D16 Inc/Dec SW R(769) Monitor (1-22) E/G failure lamp
R I GSM(32) A-15 24 Br(554)
(912-c)
FA8 (10A, Controller)
(962) Service brake secondary A26 DEC 6 STOP
[W] [R] 20 20
100A B E pressure sensor (for declutch) A27 E 16 (B) WARNING
FA9 (10A, ECM1) (GY)(138)
D17 GPS 45
5
YB(724) (472)
MAINTENANCE
FA10 (10A, ECM2) A/C gas pressure sensor A30 2
(912-d) B3
100A
100A
[W]
FA6 (10A, Horn) Heater relay (P)(129)
D18 A31 LgR(718)
41
FA7 (10A, Flasher)
(963) (709) Air heater Alternate droop
[R]15 [B]15 Secondary steering check (YB)
(331) 23
pressure sensor (opt) (LW)(136)
D19 A25 Ride control (opt) (Gr)(579)
ECM (710)GW (708)BL
ECM(11) (WB)(332) 12 A-9(TXD) 25
B (10) A24
Hydraulic oil (WL)(142) (YR)(577) C-4 9
(965) C01 19 (WAKE UP) WB(721)
[R]x4 E temperature sensor (BW)(113) B06 10
E T/M oil temp. (Gr)(578) A-8(RXD)
C02 B07 28
sensor (Br)(141) 43
(965-g)
[R]
FA1 (5A, Back lamp) E Axle oil temperature sensor C07 A07 (Key SW M) (Y)(021)
15 A-10
FA2 (5A, Brake lamp) (LR)(143) FA13 (DG_IN1) 20
Atmospheric temperature sensor C08 A06 (R) 16
FA3 (10A, Head lamp) (GB)(124)
(Battery) (011)
(965-e)
[R]
F17(-)
C03
(BrY)(535) Lift arm height kickout (opt) FA8
17 22 (BY)
(593) ICF E
FA12 ((20A), Opt (ACC2)) (YL)(101) 33
(965-b)
R
T/C input rev. sensor WY L
(WB)(182)
E17 C04
(LY)(536)
Lift arm lower kickout (opt) Alternator (L)
(GW)(707)
32
34
ECM (50 poles)
FA14 (5A, Neutral relay) (E/G speed) E07
FA15 (10A, MC PPV power) (RW) (Br) BR
FA20 (965-c) E BR(895) GW(710)
(965-f)
FA16 (10A, Loader control) T/M output shaft rev. sensor WY L (YL)(105)
E18 C11
(455)
C5
(068) R Secondary steering GSM Coolant level H SW
5 10
Heater relay
[R] pump relay (opt) 7 11
BL(708)
FA17 (20A, Rear working lamp) (Machine speed) (GB)(184)
E08 5A
BR
FA18 (5A, Parking brake) C5
E
BY(896)
6 27
GY(591) Monitor (1-11)
(965-c)
WY L (LW)(102) (LR)(525)
Coolant level L SW Overheat (2) warning lamp
R FA19 (10A, Hi beam) E19 ES V(592)
FA20 (5A, Secondary steering) T/C output rev. sensor (YB)(186)
2A 19 8 Monitor (1-12)
E09 E
(965-h) E/G oil pressure (2) warning lamp
R FB2 (10A, 24V socket)
T/M intermediate shaft
(965-d)
FB3 (15A, Front wiper)
speed sensor
WY L (WR)(103)
(LB)(188)
E20 Back lamp relay ECM (31 poles)
[R] FB4 (20A, Front working lamp) (Machine speed backup) E10 (LB)(405) (Y)(021)
C17 C2 (Key SW M) FA13 E
FB5 (10A, Rear wiper)
R(011)
(965-j) (GR)(595)
Shift up delay indicator (SW built-in) (Battery) FA8 1-1 1-28
[R] FB6 (10A, A/C 1) C05 Y(021)
FB7 (10A, DC/DC converter) (Key SW M) FA13 1-2
(965-k) E
R
FB8 (15A, Seat heater) E Open:
(Br)(456)
FB9 (10A, Revolving lamp) C12 Axle oil cooler relay (opt) active (WL)(272)
(965-l) E Hourmeter stop SW 1-3
R
FB10 (20A, A/C 2) (GR)(235) Air cleaner clogging SW
(RL)(151)
1-18
(M)
(965-a) Shift lever (gear) Shift hold switch E22 Hydraulic oil level sensor
[R] FB13 ((15A), Opt (ACC3)) Downshift switch 1
(M)
(RB)(552) Monitor (1-19) Low steering oil pressure 1-17
BR FB14 ((10A), Opt (ACC4)) 7 8 6 (PW)(236) C09 Model select 1 (factory use only)
Downshift switch 2
(M)
E23
alarm indicator (opt) 1-4
1 (WR)(555)
Model select 2 (factory use only) 1-5
Declutch SW C10 Monitor (1-6) Parking brake indicator
2 (LY)(247) (O)(553)
Shift up delay indicator 8 E16(1) C06 Monitor (1-32) Brake oil low pressure indicator E
3 Shift lever (gear) 6 (BrY)(248) (V)(542)
C2 relay (back-up lamp relay) 7 E21(2) B17 Monitor (1-23) T/M trouble (1) alarm lamp
4 (YB)(153) (LR)(529) (Y)(021) (Key SW M)
A1,C1 relay (ECM main relay) 2-35 2-5
4 F (WR)(241) (RL)(261) Fuel level sensor (Gr)(154) FA13 Buzzer
A/C control unit (21) E14(F) 2-36
Shift lever (FNR) 1 N (YG)(262)
Buzzer (monitor) Shift lever (FNR) (LY)(242)
E13(N)
1 4 3 2 3 R (GW)(243) (WL)(263)
ICF(C-7) 2 E15(R)
F E (V)(592) (461)(L)
ECM (38) N Engine oil pressure (2) ECM (8) 1-12 2-17 Load dump1 relay
GSM(15),GPS(A-1) R BR Overheat (2) ECM (27) (GY)(591)
1-11 2-16
(462)(V)
Load dump2 relay
(965-b) (033) (451) (Br)(554) (447)(RW)
MC(E04) R FA14 (O) (PB) Engine failure ECM (6) 1-22 2-19 Wiper relay (Lo)(F1)
Neutral relay B6
E (WR)(556) (448)(PB)
Monitor (1-2) 5A Heater (1) ECM (4) 1-21 2-18 Wiper relay (Hi)(F2)
M
B1 relay (Parking brake) Alternate droop relay B3 AUTO1
(BrW)(254)
Auto/manual selection switch F23(MODE2) (YR)(543)
Steering pressure switch (opt) BR AUTO2 (V)(255) Neutral relay 1-24
(543)(YR) F22(MODE1) (WR)(555)
J-A Monitor (1-24) Parking brake MC(C10) 1-6
(LB)(253) (RB)(552)
E Fan reverse switch (Auto) (opt) D23 D02 S1H Steering pressure alarm MC(C09) 1-19
(O)(553)
Fan reverse switch (Manual) (opt) (M) (WL)(252)
F07 D03
S1L Service brake alarm MC(C06) 1-32
(O)(278) (V)(542)
(WL)(244)
D12(F) Transmission failure (1) MC(B17) 1-23
Forward/reverse switch (opt) (YB)(246) (BrW)(279)
D13(R) Secondary steering operation (M) (PW)(259)
check switch (opt) F08
S1H (GL)(226)
Forward/reverse selector switch (opt) (Br)(249) D04 Front washer SW 1-34
D11
Power mode selector (M) (Gr)(251) S1L CAN1 (PB)(228)
F10 D05 Front wiper SW (Lo) 1-29
ON1 (GY)(268) S1S (BrY)(229)
E11(D) Quick power switch (M) (RY)(258) Front wiper SW (Hi) 1-30
Declutch position switch ON2 (WG)(267) F11
(BY)(227)
E03(N) (LY)(257) Front wiper SW (Int) 1-20
(BrY)(218) Ride control switch (Auto) (opt) F21(AUTO) (GW)(707)
2-28
FA13 (Y)(021)
(LY)(217) Alternator (L) 2-30
(M) (GR)(270) S1H
(Key SW M) Shift up delay switch (opt) D24
(YR)(514) S1L
(PB)(299) Lighting switch 1-25
Transmission learning switch E12 (LR)(501) 2-29 S1H
(GrL)(293) Turn signal (R) 2-15
Lift arm auto leveler up SW (opt) F13(ON) Arm angle learning switch (GW)(298) E24 (RL)(502) S1L CAN1
(M) (WG)(294) Turn signal (L) 2-14
F14(SET) (GY)(511) S1S
B01 High beam 2-13
(LW)(517)
(LB)(295)
F18(ON) E B08
Working lamp 2-12
Lift arm auto leveler down SW (opt) (M) (WY)(296)
F19(SET)
B10
-2- E
(Key SW M) FA13
(Y)(021)
E04 B20 MONITOR
MC (Main Controller) 09708-07621
ZW310-5A Electrical Connection Diagram (2/2)
Lighting SW (021)
E BR E
(Y)
(Light) (Dimmer) (Key SW M) FA13 21 (965-f)
Lock valve SW
18
(622)(Gr)
[R5] FA16
(081)
YG
E
(222)(GR)
16 15 C C 13 14 C6
OFF Hi (621)(GR) Blow-off 10A
A/C unit 5 22W
SM Lo internal wiring (620)(YR)
servo motor C6 (605)(RY)
(628)
(Lg) 4 M Lock valve solenoid (opt) B
H CR 23 MV (912-d) (015)
A9
[W3] FA6 P 2.2A
E (629) (625)(WB) (527)WB
Lighting SW (GW)
14 (431) A4 10A Horn (High)
BM 24 (WR) 2.2A
13
(421)(RY)
A3 High beam relay A/M
Air conditioner unit

3 (623)(O) Bucket detent Horn (Low)
(626) (624)(BL)
servo motor 62 (211)(GB)
14 (422)(Gr)
Head lamp relay 2 M A9 Horn SW
B (912-b) (016)
A2 (BR)
28 (215)
[W3] FA4 Br
M 27 (611) MAM (LR) Bucket leveler Horn SW (Side)
Working lamp SW (627) A4
16 MRF (WR) 12
(WG)
Solar insolation (proximity SW)
10A (514) (464) (425)(YR) sensor Flasher unit
B YR (PB) A6 Front working lamp relay Inside/outside (612)(P) (535)(BrY) (912-d) (Hazard) J-A
15 11 MC(C-3)(opt) [W3] FA7
(014)
air servo motor (616)(GR)
YR B E
C3 Front working lamp relay (opt) 20 10A L
A/C unit (432)(BrY) A5 A8
(464) (619) internal wiring Lift arm height kickout (411) (501)
(426)(RW)
62 detent B BrY LR 25W
Front turn signal (R)
(PB) A7 Rear working lamp relay 16 (PB) Inside air thermistor
THI (208)
(618) 25W
C4 Rear working lamp relay (opt) (BY)
A5 (RG) Height kickout Rear turn signal (R)
19 Blow-off thermistor (proximity SW)
(615) THF
Monitor
(515) 15
(Y) Atmospheric (536)(LY) (2-15)
FA11 P
5W
THAM temp. thermistor MC(C-4)(opt)
Width lamp (L) B7 (502)
10A 5W (605)(LW) AC gas Hi/Lo RL 25W
36
SPHL pressure SW
(433)(LY) Lift arm lower kickout Front turn signal (L)
Width lamp (R) ACM detent (float)
10W 40 62 25W
Rear turn signal (L)
Tail lamp (L)
10W S1H Monitor
Tail lamp (R)
8
S1L
Coupler SW (opt) (2-14)
9
S1H (205)
(341) Coupler PULL (Gr)
Lever safety lock SW (opt) 7 6
S1L CAN1 (LR)
Lever safety lock SW (opt) (631) (630) S1S
BR A/C unit (LB) (BrY) (M) Hazard SW (412)
F/R shift select SW (opt) internal wiring (L)
(965-l)
[R2] FB10 LR
(085) BM MB BR Turn signal SW
Fan reverse SW (AUTO) 2 4 (342) Coupler PUSH (415) A8
Fan reverse SW (MANUAL) 20A M 3 1 Blower motor (GB) (965-g) (062)
[R3] FA2 (LB) 12 11 R (413)(RW) (PW)
PTR
(965-j) CR (414)(LY) (416)(WR)
Secondary steering [R3] FB6
(084)
ECC 5A 10 L
B7
Gr (601)G
check SW (opt) 10A Compressor clutch
Power mode SW BR 1.5A
Ride control SW (AUTO)(opt) (965-h) (087) Cigar lighter (+24V) (206)
[R3] FB2 B4 (BrW)
B
WR Brake lamp switch
Parking brake SW Radio 10A
Working lamp SW (912-b) (802) B4 (503) 25W
[W3] FA5 P2 Optional power (WR)
Working lamp SW supply (battery)
(+)10
R Brake lamp (RH)
(-)6
(15A) (001) Flasher (Revolving light)
Hazard SW (GR) 25W
(KEY SW ACC) 8 (+)9 (opt) Brake lamp (LH)
Monitor (1-25) E (912-a) FB1 L
(965-k)
FB9
(091)
L1.25
(017)
[W] FB11 LW
(-)5 R3 Flasher SW
7 4 10A
5A (965-g) C2 (505) (506) 0.5A
2.3A [W3] FA1 (063)(V) (BrW) (WG)
B Cab wiring 5A Back-up alarm
Door switch
12W
Back lamp RH
E
Parking switch Dome light Seat heater 12W
10Wx2 (965-k) (089) SW (opt) Seat heater Back lamp LH
(021)(Y)
(202)
(GO)
ON1 ON1: Alternate (apply brake) R3 FB8 LR2 Front wiper motor
(Key SW M) FA13 B1 (ON2): Momentary (release) 3.8A
(965-h) (082)
(409) (402) (201) (ON2) 15A [R3] FB3 G1.25 2~15A Lo (441)W F2
B1
(406)
(Gr)
B2
(RW) (Y) (Br) ON1
Dome light Air suspension M
10W seat 5.6A 15A
(442)O
J-A (ON2) (B pillar) (blown at 19.5A)
Hi (443)
V
BR Parking relay B2
(444)Y F1
(408)(GW)
(965-f) (BW) Parking solenoid (407)

[R5] FA18 (061) (P)
BR
5A (965-g) (072) F1 (RW)(447)
0.81A DC-DC converter (opt) A2 (512) Monitor (2-19)
(965-j)
FB7 (088) [R3] FA3 R 70W
[R3] WB
-
YB
Head lamp (LH)(Lo) (PB)(448)
Front wiper SW
BR E + 10A F2 Monitor (2-18)
10A 7 2 3 14 6
Head lamp (LH)(Hi) Front washer motor OFF
75W
B8
(531)WL 1.6A Int
S1H (538) W M
+12V + Cigar lighter 70W
Head lamp (RH)(Lo) (226)
Low
S1L (539) GL
S1H 0 - (+12V) Monitor (GL) High
10A (965-c) (073) A3 (1-34) Front wiper SW Washer
S1L CAN1 5A FA19 (511) Head lamp (RH)(Hi) (225)
R2 P (LW)
S1S
GY 75W B8 (224)(BrW)
6 1
10A (227)(BY)
Monitor (2-13) Monitor (1-20) 7 Rear wiper SW
(228)(PB)
(965-d) (074)
Monitor (1-29) 3 1 9 10 11
[R5] FB4 P2
A6 (517)
Monitor (1-30)
(229)(BrY)
4
(965-e) (808) LW 70W Washer
R2 FA12 WR2 20A Cab front working lamp (RH)
Opt power (ACC1) (965-d) Rear wiper SW OFF
(20A) E 70W [R5] FB5
(083) Low
To rear view camera Cab front working lamp (LH) WR
B9 (231)(RW) 9
Washer
(965-a)
FB13 (812) 10A 10 1 low
OPT CAN [R3] WB1.25 Monitor (2-12)
Opt power (ACC2) BR B10 (232)(LY) 11
(15A) B9
C3 (519) (446)RG 1~6A
Rear view monitor (opt) E WB 70W M Rear wiper motor
(965-a) (813) Cab front working lamp(RH)(opt)
(808) [R3] FB14 WL
(WB) + - Opt power (ACC3) 70W (445)V
(10A) Cab front working lamp(LH)(opt)
S1H B10
E BR (965-f) (075)
(532)
RB
S1L [R5] FA17 W2 A7 (518)
55W M Rear washer motor
GW
S1H
20A Cab rear working lamp (RH)
CAN1 E
S1L BR 55W
S1S Cab rear working lamp (LH)
C4 (520)
70W
G
Cab rear working lamp (RH)(opt)
70W 09708-07621
Cab rear working lamp (LH)(opt)
E
-3-
ZW310-5A Fuses and Relays
Fuse Box-A Fuse Box-B
Fuse Box-A Fuse Box-B F-A F-B
Voltage Relay
20A 10A 5A 5A 20A 15A 15A 10A
VR Data link
E/G
Secondary steering
ECM2 A10 13 10A 5A 68 A20 (opt) Air conditioner 2 B10 85 20A 965l OPEN B20 Relay Box-C
965c R-C
ECM1 A9 9 10A 912c 10A 73 A19 High beam Revolving lamp (opt) B9 91 10A OPEN B19 10 20 10 20
965k 1 2 9 19 9 19
MC, ICF, Monitor
GPS, GSM, Load dump A8 11 10A 5A 61 A18 Parking brake Seat heater (opt) B8 89 15A OPEN B18 8 18 8 18
Relay Box-B 7 17 7 17
Flasher unit A7 14 10A 965f 20A 75 A17 Rear working lamp DC/DC converter B7 88 10A OPEN B17 R-B 6 16 6 16
(opt) 6 7 8 9 10 5 15 5 15
912d 965j
Horn 4 14 4 14
A6 15 10A 10A 81 A16 Loader control Air conditioner 1 B6 84 10A OPEN B16
3 13 3 13
1 2 3 4 5 2 12 2 12
OPT1 (Battery) A5 802 OPEN 10A 65 A15 MC PPV solenoid Rear wiper B5 83 10A OPEN B15 1 11 1 11
912b 965b 965d Relay Box-A
Lighting A4 16 10A 5A 33 A14 Neutral relay Front working lamp B4 74 20A OPEN 813 B14 OPT4 (Acc)
R-A
Alternate droop 6 7 8 9 10
965a
Head lamp A3 72 10A 923 10A 21 A13 Power ON Front wiper B3 82 15A OPEN 812 B13 OPT3 (Acc)
965h 1 2 3 4 5
Turn signal 24V cigar lighter
Brake lamp A2 62 5A 965g 965e OPEN 808 A12 OPT2 (Acc) B2 87 10A 905 10A 32 B12 Starter key SW
Backup alarm Radio power ON Radio

Backup lamp A1 63 5A 514 10A 515 A11 Position (tail lamp) B1 1 5A 9001 912a 5A 17 B11
Room lamp
MPDr. Dr.
FRONT
Relay Box-A Relay Box-B Relay Box-C
458 A1 0 425 A6 0 21 B1 202 33 B6 451 458 C1 0 81 C6 222
CAB front Pilot shut-off

ECM1 Parking (1) Neutral ECM2 (Loading lever
working lamp
406 705 305 lock)(opt)
9 74 21 907 13 81
713 517 711
422 A2 0 426 A7 0 406 B2 409 416 B7 0 21 C2 405 C7

Rear Parking (2) Turn (L) Backup lamp
Head light working lamp
72 75 408 411 63
512 518 0 502 505
421 A3 0 415 A8 0 33 B3 451 882 B8 225 425 C3 0 C8
High beam Turn (R)

Engine Front washer
CAB front working
lamp (opt)
Fuse Box &
73 411
alternate droop
718 82 74
Relay Box
511 501 721 531 519
81 A4 215 15 A9 211 62 B4 206 83 B9 231 426 C4 0 C9 Wiper Relay

CAB rear working
Bucket leveler Horn Brake lamp Rear wiper lamp (opt)
445
431 15 62 446 75
0 527 503 83 520
81 A5 208 11 A10 462 11 B5 461 83 B10 232 68 C5 455 C10

Lift arm Secondary steering
Load dump 2 Load dump 1 Rear washer (opt)
height kickout 0
432 11 11 83 68
457 471 532 525
82 F1 447
CAN1 (J1939) Front wiper motor (Lo)
Power Train Rear view 443
444
Monitor ICF MC A/C INSITE monitor OPT CAN ECM 0

S1H S1H S1H S1H S1H S1H S1H S1H
2-30 C-5 D2 8 C 46 82 F2 448
S1L S1L S1L S1L S1L S1L S1L S1L
2-29 C-11 D3 9 D 37
Front wiper motor (Hi)
S1 441
36
443
S1H 442
-4- S1L
Terminator
09708-07621
ZW310-5A Front Chassis Wiring Diagram CN.004
WKL 502-01
R-L
Front combination CN.008 CN.033
1 CB001
lamp (Turn signal (L))
3 1 CN.031
CN.006
To rear chassis main
208-01 000-11 000-11 208-01
FCL 000-03 R-G B B R-G Lift arm kickout
Center Harness Front Chassis Harness 1 B Front combination LPS LPS BPS 208-01 000-11
CA001
lamp LH GND R-G B proximity SW
CN.043 CN.041 CN.001
123-01 135-01 124-02
W Y G-B
To rear main CN.211 CN.005 6 4
YAZAKI SWP
7123-1424-40
1 1 YAZAKI SWP YAZAKI SWP Gray
1 4 4 4 WLL 515-03
7123-7464-40 7222-7464-40
P
341-01 342-01 122-01 121-01 121-01 122-01 342-01 341-01 341-01 342-01 122-01 121-01 1 CB001 Front combination
L-R G-B V P P V G-B L-R L-R G-B V P
lamp (width lamp L) CN.017 CN.019
R1 F1 F1 Head light RH Front combination lamp
131-01 123-01 135-01 135-01 123-01 131-01 131-01 123-01135-01 CN.007 WKR 501-01
R-L W Y Y W R-L R-L W Y 1 3 1
L-R (Turn signal (R))
3 1 CB001
5 8 8 5 5 8 000-04 511-02 512-02 000-06 511-03 512-03
YAZAKI SWP YAZAKI SWP YAZAKI SWP
7222-7484-40
HLL Head light LH HLR B G-Y Y-B
7222-7484-40 7123-7484-40 B G-Y Y-B
white tape
CN.021
CN.044 JN.A02
YAZAKI SWP YAZAKI SWP
7123-7434-40 Front combination lamp
CN.042 CN.002 7123-7434-40
FCR 000-07
RH GND
To rear main CN.216 JN.A06 JN.A03 JN.A01 white tape white tape 1
B
CA001
3 1 1 3
1 2 3
515-01 332-01 331-01 331-01 332-01 515-01 CN.018
331-01 332-01 515-01
Y-B W-B P P W-B Y-B Y-B W-B P Coupler (Opt)
1.25 1.25 1.25 CN.020 Front combination lamp
4 5 6 7
502-01 512-01 511-01 527-01
7 527-01 511-01 512-01 502-01 4 4 502-01 512-01 511-01 527-01 7 3 1
WLR 515-02 (width lamp RH)
R-L Y-B G-Y W-B W-B G-Y Y-B R-L R-L Y-B G-Y W-B 341-01 000-02 342-01 P
1.25 1.25 1.25 1.25 R2 F2 F2 COUP L-R B G-B
1 CB001
8 9 10 501-01 208-01
501-01 208-01
L-R R-G
white tape
10
208-01 501-01
R-G L-R 8 8 10 CN.022
L-R R-G YAZAKI SWP YAZAKI SWP
11
1.25
12
1.25
13 14 CN.014 Bucket leveler 7123-7434-40 7222-7434-40
215-01 124-01 141-01 000-01 000-01 141-01 124-01 215-01 215-01 124-01 141-01 000-01
Axle oil temperature sensor proximity SW
L-R
1.25
G-B
1.25
Br
1.25
B
1.25
B Br G-B L-R
11 11 L-R G-B Br B CN.003
14 14
2 1 2 1
YAZAKI SWP YAZAKI SWP YAZAKI SWP 2 1
BPS 000-08 215-01
7222-7544-40
7123-7544-40 7222-7544-40 FT 124-03 141-01
B L-R 332-01 331-01
Ride control solenoid CN.012
G-B Br RC W-B Y-B (YA-7120-3011)
YAZAKI SWP 000-10

YAZAKI 090-2 7123-1424-40 B Horn (high)
7283-7027-40 SUMITOMO MT090 SUMITOMOMT090 1 7116-2270
Gray 6189-0031 6180-2405
HA CN.013
CN.015 000-01
000-02
JN.A05 JN.A04 (YA-7120-3011)
527-03
GND 000-03
CN.016 1 W-B Horn (high)
000-04 7116-2270
- B 000-05
000-06
CN: Connector, JN: Junction

SL01510
000-07 3 1
Lift arm (boom) raise pilot CN.010
000-08 121-01 131-01 122-01 (YA-7120-3011)
LU pressure sensor
From To
000-11 P R-L V 000-09
B
Horn (low)
Wire Wire 1 7116-2270
Wire No. YAZAKI SWP YAZAKI SWP
CN/JN CN/JN Dia. Color HB
No.
Pin
No.
Pin 7123-7434-40 7222-7434-40
CN.011
(YA-7120-3011)
1 000-01 CN.002 Center harness 2 14 CN.015 GND 1 1.25 B 527-02
W-B
Horn (low)
2 000-02 CN.015 GND 1 CN.018 Quick coupler (opt) 2 1.25 B 1 7116-2270
3 000-03 CN.006 Front combination lamp (L)(GND) 1 CN.015 GND 1 1.25 B

4 000-04 CN.007 Head light (L) 3 CN.015 GND 1 1.25 B
5 000-05 JN.A05 CN.015 GND 1 1.25 B
6 000-06 CN.017 Head light (R) 3 CN.015 GND 1 1.25 B
7 000-07 CN.021 Front combination lamp (R)(GND) 1 CN.015 GND 1 1.25 B
8 000-08 CN.022 Bucket leveler proximity SW 2 CN.015 GND 1 1.25 B
9 000-09 JN.A05 CN.010 Horn (low) 1 1.25 B
10 000-10 CN.012 Horn (high) 1 JN.A05 1.25 B
11 000-11 CN.008 Lift arm kickout proximity SW 2 CN.015 GND 1 1.25 B
12 121-01 CN.016 Lift arm raise pilot pressure sensor 3 CN.001 Center harness 1 4 1.25 P
13 122-01 CN.016 Lift arm raise pilot pressure sensor 1 CN.001 Center harness 1 3 1.25 V
14 123-01 CN.008 Lift arm kickout proximity SW 6 CN.001 Center harness 1 6 1.25 W
15 124-01 JN.A06 CN.002 Center harness 2 12 1.25 G-B
16 124-02 CN.008 Lift arm kickout proximity SW 4 JN.A06 1.25 G-B
17 124-03 CN.014 Axle oil temperature sensor 2 JN.A06 1.25 G-B
18 131-01 CN.016 Lift arm raise pilot pressure sensor 2 CN.001 Center harness 1 5 1.25 R-L
19 135-01 CN.001 Center harness 1 7 CN.008 Lift arm kickout proximity SW 5 1.25 Y
20 141-01 CN.014 Axle oil temperature sensor 1 CN.002 Center harness 2 13 1.25 Br
21 208-01 CN.008 Lift arm kickout proximity SW 3 CN.002 Center harness 2 9 1.25 R-G
22 215-01 CN.022 Bucket leveler proximity SW 1 CN.002 Center harness 2 11 1.25 L-R
23 331-01 CN.003 Ride control solenoid 1 CN.002 Center harness 2 1 1.25 Y-B
24 332-01 CN.003 Ride control solenoid 2 CN.002 Center harness 2 2 1.25 W-B
25 341-01 CN.001 Center harness 1 1 CN.018 Quick coupler (opt) 3 1.25 L-R
26 342-01 CN.001 Center harness 1 2 CN.018 Quick coupler (opt) 1 1.25 G-B
27 501-01 CN.019 Front combination lamp (turn R) 1 CN.002 Center harness 2 8 1.25 L-R
28 502-01 CN.004 Front combination lamp (turn L) 1 CN.002 Center harness 2 4 1.25 R-L
29 511-01 JN.A01 CN.002 Center harness 2 6 1.25 G-Y
30 511-02 JN.A01 CN.007 Head light (L) 2 1.25 G-Y
31 511-03 JN.A01 CN.017 Head light (R) 2 1.25 G-Y
32 512-01 JN.A03 CN.002 Center harness 2 5 1.25 Y-B
33 512-02 CN.007 Head light (L) 1 JN.A03 1.25 Y-B
34 512-03 JN.A03 CN.017 Head light (R) 1 1.25 Y-B
35 515-01 JN.A02 CN.002 Center harness 2 3 1.25 P
36 515-02 JN.A02 CN.020 Front combination lamp (width R) 1 1.25 P
37 515-03 JN.A02 CN.005 Front combination lamp (width L) 1 1.25 P
38 527-01 JN.A04 CN.002 Center harness 2 7 1.25 W-B
39 527-02 CN.011 Horn (low) 1 JN.A04 1.25 W-B
40 527-03 JN.A04 CN.013 Horn (high) 1 1.25 W-B
-5-
ZW310-5A Rear Chassis Wiring Diagram (1/2) To rear grille
CN.251 CN.210
To rear grille CN.311
CN.243 3 1
840-01 841-01 842-01
To secondary steering (opt) CN.252 For rear grille option Y-G W L
4 1
For rear console option (not used) (not used)
OPT 505-01 501-03 000-11 506-01
843-01 000-opt Br-W L-R B W-G
3 1 1
136-01 000-es 525-01 3 R B
6 4
L-W L-R 518-01 515-03 503-01 502-03
B 841-01 842-01 843-01 RG
ES RRO W L R CN.238 YAZAKI SWP YAZAKI SWP 8 G-W P W-R R-L 5
124-07 123-07 137-01 7222-7464-40 7123-7464-40
6 G-B W Br-Y 4
YAZAKI SWP Service brake primary pressure sensor 326-01 325-01
7222-7434-40 B-R W-B
3 1 12 9
YAZAKI SWP YAZAKI SWP 124-05 126-01 123-05
7222-7464-40 7123-7464-40 SB G-B Y-B W YAZAKI SWP
YAZAKI SWP 7123-7923-40
7123-7434-40
AMP EJC2
CN.224
174357-2 Fan reversing solenoid (opt) CN.218
CN.203 To Air cleaner clogging SW CN.337
Parking brake pressure sensor red tape
To rear console
To center harness
3 1 1
3 328-01 327-01 2
1
CN.202 123-06 127-02 124-08
G-Y Y-R
ACS
000-10 151-01
CN.211 To Rear Console CN.706 PP FRS B R-L
W R-L G-B 124-03 139-01 123-03 CN.230
To Center Harness CN.043 JN.C30 JN.C29 JN.C28
6
G-B Gr W
4
Fuel level sensor YAZAKI SWP
YAZAKI 91-RV 7123-1424-40
1 4 7223-6536-30
341-01 342-01 122-01 121-01 2 1 Gray
4 1 Black 154-01 153-01
121-01 122-01 342-01 341-01 L-R G-B V P 7222-7464-40 7123-7464-40 FLS Gr Y-B
CN.225
P V G-B L-R 5 8 Alternator R-terminal
R1 RRB
131-01 123-01 135-01 139-01 CN.222 AMP EJC2
135-01 123-02 131-01 R-L W Y Gr
Y W R-L
Pump swash plate tilt solenoid 174352-2
ALR 799-01
W-L
8 5 127-01 126-01 142-01 327-01
2 1 CA001
R-L Y-B W-L Y-R white tape
YAZAKI SWP 9 12
7123-7484-40
328-01 331-01 332-01 525-01 PSS
322-01 321-01 CN.242 B CN.226
L-Y R-Y
CN.216 G-Y Y-B W-B L-R JN.C11 JN.C10 To ECM GND 000-02 Alternator I-terminal
13 16 000-03
To Center Harness CN.044 000-04
ALI
707-01
YAZAKI SWP YAZAKI 62Z GND G-W
7222-7564-40 7123-8520-40
SL00506
000-05
000-06
CN.241 SL00105
3
515-02 332-01 331-01
1 Diode unit (A/C)
P W-B Y-B
CN.237 CN.221 2 1
7 527-01 511-01 512-01 502-02 4 Diode unit (parking brake) Parking solenoid 601-03 000-12
DAC
G B
W-B G-Y Y-B R-L CN.240
R2 2 1 2 1 CN.234
208-01 501-02 061-03 407-03 061-02 407-02
YAZAKI SWP YAZAKI SWP A/C compressor (GND) CN.239
DP PS Fusible link (100A-Floor) 7322-9623-40 7123-1424-40
10 R-G L-R 8 B-W P B-W P
R
Gray 000-13 A/C compressor (+)
965a-01
ACG B
000-15 141-01 124-02 215-01 YAZAKI SWP YAZAKI SWP
7322-9623-40 7123-1424-40
100 965b-01
SL00205
14 B Br G-B L-R 11 YAZAKI 62Z
Gray 7123-8521-80 SL03006 965c-01
965d-01
YAZAKI SWP white tape 1
7123-7544-40
JN.C16 JN.C14 AC+ 601-02
G
JN.C12
JN.C21 JN.C09 JN.C08 JN.C18 JN.C19 JN.C20 white tape white tape white tape JN.C31 JN.C15 JN.C13 JN.C23
B
CN.236 000-09
JN.C24 TOKAIRIKA 090-2
GND (rear) 000-10

JN.C25 CN.206 4F0178-0001
CN.228 B 000-11 ECM (50-pole)
GND (front) 000-15
-R 000-14
000-es SL00510 000-opt
-F 000-sps 10
721-03 721-02 713-03 713-02 554-02
5
724-01 556-01
2 3 1
000-wmf
SL00510 000-wmr W-B W-B L-W L-W Br Y-B W-R
CN.212 CN.220 20 19 15 11
711-02 713-04 554-03 770-01 13 12
Diode unit (washer-F) CN.213 Hydraulic oil temperature sensor CN.331 R-W L-W Br R-Y
Washer motor (F) 2 1 30 27 26 25 23 22 21
2 1 000-03 000-02 711-03 769-01 716-01
124-06 142-01 ECM
531-01 000-07 1 OTS B B R-W R W
W-L B
DWF 531-01 G-B W-L
34 33 32
531-02 000-04 000-05 021-03 S1L-b S1S-b
W-L YAZAKI SWP B B Y W Gr
YAZAKI SWP YAZAKI SWP 7123-1424-40 40 35 31
7322-9623-40 7123-1424-40 WMF Gray
Gray 000-07 CN.219 000-06 717-01 715-01
47
S1H-b 712-01
43 42
718-01
000-wmf
Starter (C) 50 B B R L 45 W-R Lg-R 41
B
2
CN.215 YAZAKI CN
704-01
R-G STC DEUTSCH DRC
Diode unit (washer-R) 7123-2228
SL00105 DRC26-50S01
White
2 1
CN.232 CN.229
Battery relay (SW) CAN resistor
532-01 000-08
DWR CN.214
R-B B CN.207
Washer motor (R) 911-01
R + ECM (31-pole)
7322-9623-40 7123-1424-40
532-01 1 CN.209 SL00808 A
S1H-a S1L-a
B B A
Gray
532-02 Battery power L W
R-B 20 31
8
WMR 1
RGT
To rear console JN.C22 000-08
000-wmr RRC
912-01
W
21
592-01
V
30
CN.268 C C 9 19
896-01
B
CN.201 2 YAZAKI 58Y To Battery relay CN269 DEUTSCH DT DEUTSCH DT
10 2 B-Y 18
7123-4210-40 710-01
To rear console CN.705 YAZAKI CN
7123-2228-90 Gray 2 1
DT06-3S-CE05 DT04-3P-P006
22 G-W 3 7 29
5 3 Blue 895-01
701-01 000-09 11 1 B-R 17
8 1 W-B B BR ECM2 708-01
515-01 503-01 502-01 501-01 505-01 506-01 151-01 701-01 CN.205 23 B-L 4 6 28
P W-R R-L L-R Br-W W-G R-L W-B 896-01
To rear console CN.709 YAZAKI SWP
7123-1424-40 12 5 B-Y 16
18 15 10 9 895-01
Gray
S1S-c1 S1L-c S1H-c 021-01 713-01 711-01 137-01 326-01 325-01 518-01
2 1 CN.233 13 B-R 15
Gr W L Y L-W R-W Br-Y B-R W-B G-W
26
19
RRE
965b-01 965a-01 Fusible link (70A-Floor) 24 14 27
215-01 512-01 769-01 770-01 712-01 717-01 716-01 715-01 R R 591-01
912-01 25 26 G-Y
20
L-R Y-B 25 R R-Y W-R B W R YAZAKI 58Y CN.217 70 W
30
RRA CN.204 7123-4220-30
To Heater relay CN.333 SL00806
8.0
Black
554-01 556-01 840-01 141-01 721-01 124-01 511-01 718-01 To rear console CN.708
34 Br W-R Y-G Br W-B G-B G-Y Lg-R 2 1 DEUTSCH HD
40 27 white tape HD36-24-31ST
407-01 061-01 322-01 321-01 532-02 531-02 592-01 591-01 136-01 724-01 2 1 708-01 710-01
GRC CN.223
965d-01 965c-01
44 P B-W L-Y R-Y R-B W-L V G-Y L-W Y-B 35 RRD R R
B-L G-W
Fusible link (70A-Battery relay)
-6- 208-01 527-01 799-01 707-01 704-01 601-01 154-01 153-01 YAZAKI SWP 911-01
YAZAKI 58Y 7123-1424-40 R
R-G W-B W-L G-W R-G G Gr Y-B YAZAKI SWP
52 45 7182-5055-40 7123-4220-40 Gray SL00806
8.0 33194-49880
Gray
50 47
ZW310-5A Rear Chassis Wiring Diagram (2/2)
CN: Connector, JN: Junction CN: Connector, JN: Junction
From To Wire From To Wire
Wire No. Wire Wire No. Wire
Dia. Color Dia. Color
CN/JN No. Pin CN/JN No. Pin CN/JN No. Pin CN/JN No. Pin
1 000-02 CN.206 ECM (50-pole) 29 CN.242 ECM (GND) 1 0.85 B 71 502-01 JN.C19 CN.201 Rear console CN705 6 0.85 R-L
2 000-03 CN.206 ECM (50-pole) 30 CN.242 ECM (GND) 1 0.85 B 72 502-02 JN.C19 CN.216 Center harness (2) 4 0.85 R-L
3 000-04 CN.206 ECM (50-pole) 40 CN.242 ECM (GND) 1 0.85 B 73 502-03 CN.210 Rear grille 5 JN.C19 0.85 R-L
4 000-05 CN.206 ECM (50-pole) 39 CN.242 ECM (GND) 1 0.85 B 74 503-01 CN.210 Rear grille 6 CN.201 Rear console CN705 7 0.85 W-R
5 000-06 CN.206 ECM (50-pole) 50 CN.242 ECM (GND) 1 0.85 B 75 505-01 CN.210 Rear grille 4 CN.201 Rear console CN705 4 0.85 Br-W
6 000-07 CN.213 Washer motor (F) 2 CN.212 Diode unit (washer-F) 1 0.85 B 76 506-01 CN.210 Rear grille 1 CN.201 Rear console CN705 3 0.85 W-G
7 000-08 CN.215 Diode unit (washer-R) 1 CN.214 Washer motor (R) 2 0.85 B 77 511-01 CN.216 Center harness (2) 6 CN.201 Rear console CN705 28 0.85 G-Y
8 000-09 CN.268 Battery relay (coil) 1 CN.236 GND (rear) 1 0.85 B 78 512-01 CN.201 Rear console CN705 25 CN.216 Center harness (2) 5 0.85 Y-B
9 000-10 CN.218 Air cleaner clogging SW 2 CN.236 GND (rear) 1 0.85 B 79 515-01 JN.C20 CN.201 Rear console CN705 8 0.85 P
10 000-11 CN.210 Rear grille 2 CN.236 GND (rear) 1 0.85 B 80 515-02 JN.C20 CN.216 Center harness (2) 3 0.85 P
11 000-12 JN.C13 CN.241 Diode unit (A/C) 1 1.25 B 81 515-03 CN.210 Rear grille 7 JN.C20 0.85 P
12 000-13 JN.C13 CN.240 A/C compressor (GND) 1 1.25 B 82 518-01 CN.210 Rear grille 8 CN.201 Rear console CN705 9 0.85 G-W
13 000-14 JN.C13 CN.236 GND (rear) 1 1.25 B 83 525-01 CN.202 Rear console CN706 16 CN.243 Secondary steering (opt) 1 0.85 L-R
14 000-15 CN.228 GND (front) 1 CN.216 Center harness (2) 14 0.85 B 84 527-01 CN.216 Center harness (2) 7 CN.201 Rear console CN705 51 0.85 W-B
15 000-es CN.228 GND (front) 2 CN.243 Secondary Steering (opt) 2 0.85 B 85 531-01 CN.212 Diode unit (washer-F) 2 CN.213 Washer motor (F) 1 0.85 W-L
16 000-opt CN.251 For rear grille option 5 CN.236 GND (rear) 1 0.85 B 86 531-02 CN.213 Washer motor (F) 1 CN.201 Rear console CN705 39 0.85 W-L
17 000-wmf CN.213 Washer motor (F) 2 CN.228 GND (front) 1 0.85 B 87 532-01 CN.215 Diode unit (washer-R) 2 CN.214 Washer motor (R) 1 0.85 R-B
18 000-wmr CN.214 Washer motor (R) 2 CN.228 GND (front) 1 0.85 B 88 532-02 CN.201 Rear console CN705 40 CN.214 Washer motor (R) 1 0.85 R-B
19 021-01 CN.201 Rear console CN705 15 CN.206 ECM (50-pole) 38 0.85 Y 89 554-01 JN.C31 CN.201 Rear console CN705 34 0.85 Br
20 061-01 JN.C10 CN.201 Rear console CN705 43 0.85 B-W 90 554-02 JN.C31 CN.206 ECM (50-pole) 6 0.85 Br
21 061-02 JN.C10 CN.221 Parking brake solenoid 2 0.85 B-W 91 554-03 JN.C31 CN.206 ECM (50-pole) 16 0.85 Br
22 061-03 JN.C10 CN.237 Diode unit (parking brake) 2 0.85 B-W 92 556-01 CN.201 Rear console CN705 33 CN.206 ECM (50-pole) 4 0.85 W-R
23 121-01 CN.211 Center harness (1) 4 CN.202 Rear console CN706 4 0.85 P 93 591-01 CN.201 Rear console CN705 37 CN.207 ECM (31-pole) 27 0.85 G-Y
24 122-01 CN.211 Center harness (1) 3 CN.202 Rear console CN706 3 0.85 V 94 592-01 CN.201 Rear console CN705 38 CN.207 ECM (31-pole) 8 0.85 V
25 123-01 JN.C08 CN.202 Rear console CN706 6 0.85 W 95 601-01 JN.C12 CN.201 Rear console CN705 47 1.25 G
26 123-02 JN.C08 CN.211 Center harness (1) 6 0.85 W 96 601-02 CN.239 A/C compressor (+) 1 JN.C12 1.25 G
27 123-03 CN.224 Fan reversing solenoid (opt) 4 JN.C08 0.85 W 97 601-03 JN.C12 CN.241 Diode unit (A/C) 2 1.25 G
28 123-04 JN.C30 JN.C08 0.85 W 98 701-01 CN.268 Battery relay (coil) 2 CN.201 Rear console CN705 1 0.85 W-B
29 123-05 CN.238 Service brake primary pressure sensor 1 JN.C08 0.85 W 99 704-01 CN.219 Starter SW C-terminal 1 CN.201 Rear console CN705 48 1.25 R-G
30 123-06 CN.203 Parking brake pressure sensor 3 JN.C30 0.5 W 100 707-01 CN.226 Alternator I-terminal 1 CN.201 Rear console CN705 49 0.85 G-W
31 123-07 JN.C08 CN.243 Secondary Steering (opt) 5 0.85 W 101 708-01 CN.217 Heater relay 2 CN.207 ECM (31-pole) 11 0.85 B-L
32 124-01 JN.C09 CN.201 Rear console CN705 29 0.85 G-B 102 710-01 CN.217 Heater relay 1 CN.207 ECM (31-pole) 10 0.85 G-W
33 124-02 JN.C09 CN.216 Center harness (2) 12 0.85 G-B 103 711-01 CN.201 Rear console CN705 13 JN.C16 0.85 R-W
34 124-03 CN.224 Fan reversing solenoid (opt) 6 JN.C09 0.85 G-B 104 711-02 CN.206 ECM (50-pole) 18 JN.C16 0.85 R-W
35 124-04 JN.C09 JN.C28 0.85 G-B 105 711-03 CN.206 ECM (50-pole) 28 JN.C16 0.85 R-W
36 124-05 JN.C09 CN.238 Service brake primary pressure sensor 3 0.85 G-B 106 712-01 CN.201 Rear console CN705 22 CN.206 ECM (50-pole) 44 0.85 W-R
37 124-06 JN.C09 CN.220 Hydraulic oil temperature sensor 2 0.85 G-B 107 713-01 CN.201 Rear console CN705 14 JN.C14 0.85 L-W
38 124-07 JN.C09 CN.243 Secondary Steering (opt) 6 0.85 G-B 108 713-02 CN.206 ECM (50-pole) 7 JN.C14 0.85 L-W
39 124-08 CN.203 Parking brake pressure sensor 1 JN.C28 0.5 G-B 109 713-03 CN.206 ECM (50-pole) 8 JN.C14 0.85 L-W
40 126-01 CN.238 Service brake primary pressure sensor 2 CN.202 Rear console CN706 10 0.85 Y-B 110 713-04 JN.C14 CN.206 ECM (50-pole) 17 0.85 L-W
41 127-01 CN.202 Rear console CN706 9 JN.C29 0.85 R-L 111 715-01 CN.201 Rear console CN705 19 CN.206 ECM (50-pole) 48 0.85 R
42 127-02 CN.203 Parking brake pressure sensor 2 JN.C29 0.5 R-L 112 716-01 CN.201 Rear console CN705 20 CN.206 ECM (50-pole) 21 0.85 W
43 131-01 CN.211 Center harness (1) 5 CN.202 Rear console CN706 5 0.85 R-L 113 717-01 CN.201 Rear console CN705 21 CN.206 ECM (50-pole) 49 0.85 B
44 135-01 CN.211 Center harness (1) 7 CN.202 Rear console CN706 7 0.85 Y 114 718-01 CN.201 Rear console CN705 27 CN.206 ECM (50-pole) 41 0.85 Lg-R
45 136-01 CN.201 Rear console CN705 2 CN.243 Secondary Steering (opt) 3 0.85 L-W 115 721-01 CN.201 Rear console CN705 30 JN.C15 0.85 W-B
46 137-01 CN.201 Rear console CN705 12 CN.243 Secondary Steering (opt) 4 0.85 Br-Y 116 721-02 JN.C15 CN.206 ECM (50-pole) 9 0.85 W-B
47 139-01 CN.224 Fan reversing solenoid (opt) 5 CN.202 Rear console CN706 8 0.85 Gr 117 721-03 CN.206 ECM (50-pole) 10 JN.C15 0.85 W-B
48 141-01 CN.216 Center harness (2) 13 CN.201 Rear console CN705 31 0.85 Br 118 724-01 CN.206 ECM (50-pole) 5 CN.201 Rear console CN705 35 0.85 Y-B
49 142-01 CN.220 Hydraulic oil temperature sensor 1 CN.202 Rear console CN706 11 0.85 W-L 119 769-01 CN.201 Rear console CN705 24 CN.206 ECM (50-pole) 24 0.85 R
50 151-01 CN.218 Air cleaner clogging SW 1 CN.201 Rear console CN705 2 0.85 R-L 120 770-01 CN.201 Rear console CN705 23 CN.206 ECM (50-pole) 14 0.85 R-Y
51 153-01 CN.230 Fuel level sensor 1 CN.201 Rear console CN705 45 0.85 Y-B 121 799-01 CN.225 Alternator R-terminal 1 CN.201 Rear console CN705 50 0.85 W-L
52 154-01 CN.230 Fuel level sensor 2 CN.201 Rear console CN705 46 0.85 Gr 122 840-01 CN.251 For rear grille option 3 CN.201 Rear console CN705 32 0.85 Y-G
53 208-01 CN.216 Center harness (2) 9 CN.201 Rear console CN705 52 0.85 R-G 123 841-01 CN.252 For rear console option 1 CN.251 For rear grille option 2 0.85 W
54 215-01 CN.216 Center harness (2) 11 CN.201 Rear console CN705 26 0.85 L-R 124 842-01 CN.252 For rear console option 2 CN.251 For rear grille option 1 0.85 L
55 321-01 CN.222 Pump swash plate tilt solenoid 1 CN.201 Rear console CN705 41 0.85 R-Y 125 843-01 CN.252 For rear console option 3 CN.251 For rear grille option 6 0.85 R
56 322-01 CN.222 Pump swash plate tilt solenoid 2 CN.201 Rear console CN705 42 0.85 L-Y 126 895-01 CN.207 ECM (31-pole) 5 CN.207 ECM (31-pole) 7 0.85 B-R
57 325-01 CN.210 Rear grille 9 CN.201 Rear console CN705 10 0.85 W-B 127 896-01 CN.207 ECM (31-pole) 6 CN.207 ECM (31-pole) 19 0.85 B-Y
58 326-01 CN.210 Rear grille 10 CN.201 Rear console CN705 11 0.85 B-R 128 911-01 CN.223 Fusible link (70A-Battery relay) 1 CN.232 Battery relay (SW) 1 8.0 R
59 327-01 CN.224 Fan reversing solenoid (opt) 1 CN.202 Rear console CN706 12 0.85 Y-R 129 912-01 CN.233 Fusible link (70A-Floor) 1 CN.209 Battery power 1 8.0 W
60 328-01 CN.224 Fan reversing solenoid (opt) 2 CN.202 Rear console CN706 13 0.85 G-Y 130 965a-01 CN.234 Fusible link (100A-Floor) 1 CN.205 Rear console CN709 1 8.0 R
61 331-01 CN.216 Center harness (2) 1 CN.202 Rear console CN706 14 0.85 Y-B 131 965b-01 CN.205 Rear console CN709 2 CN.234 Fusible link (100A-Floor) 1 8.0 R
62 332-01 CN.216 Center harness (2) 2 CN.202 Rear console CN706 15 0.85 W-B 132 965c-01 CN.204 Rear console CN708 1 CN.234 Fusible link (100A-Floor) 1 8.0 R
63 341-01 CN.211 Center harness (1) 1 CN.202 Rear console CN706 1 0.85 L-R 133 965d-01 CN.204 Rear console CN708 2 CN.234 Fusible link (100A-Floor) 1 8.0 R
64 342-01 CN.211 Center harness (1) 2 CN.202 Rear console CN706 2 0.85 G-B 134 S1H-a JN.C23 CN.229 CAN terminator 1 0.5 L
65 407-01 JN.C11 CN.201 Rear console CN705 44 0.85 P 135 S1H-b CN.206 ECM (50-pole) 46 JN.C23 0.5 L
66 407-02 JN.C11 CN.221 Parking brake solenoid 1 0.85 P 136 S1H-c CN.201 Rear console CN705 16 JN.C23 0.5 L
67 407-03 JN.C11 CN.237 Diode unit (parking brake) 1 0.85 P 137 S1L-a JN.C24 CN.229 CAN terminator 2 0.5 W
68 501-01 JN.C18 CN.201 Rear console CN705 5 0.85 L-R 138 S1L-b CN.206 ECM (50-pole) 37 JN.C24 0.5 W
69 501-02 JN.C18 CN.216 Center harness (2) 8 0.85 L-R 139 S1L-c CN.201 Rear console CN705 17 JN.C24 0.5 W
70 501-03 CN.210 Rear grille 3 JN.C18 0.85 L-R 140 S1S-b JN.C25 CN.206 ECM (50-pole) 36 0.5 Gr
141 S1S-c JN.C22 JN.C25 0.5 S
142 S1S-c1 JN.C22 CN.201 Rear console CN705 18 0.5 Gr
-7-
33194-49880
ZW310-5A Rear Chassis Wiring Diagram (Transmission)
To rear console CN.103 CN.104

T/M 4th speed clutch solenoid T/M 2nd speed clutch solenoid
CN.101 CN.114
To rear console CN.703 T/C input revolution sensor (E/G speed) 2 1 2 1
362-01 361-01 358-01 357-01
1 4 2 1 4 B-W R
2 B-Y R-G
101-01 182-01 102-01 186-01 182-01 101-01
L W-Y L W-Y TI
W-Y L SUMITOMO MT090 SUMITOMO MT090
5 8 6189-0031 6189-0031
103-01 188-01 105-01 184-01 YAZAKI SWP
L W-Y L W-Y 7123-1424-40
Gray
356-01 355-01 358-01 357-01 12 CN.106 CN.105 CN.107
9 RTM1 CN.112 T/M reverse clutch solenoid
G-B L-W B-Y R-G T/M 3rd speed clutch solenoid T/M 1st speed clutch solenoid
13 360-01
T/C oil temperature sensor 2 1
359-01 362-01 361-01 16 2 1
113-01 2 1
B-Y R-W B-W R
TCT B-W CN.110 360-01 359-01 356-01 355-01 R 354-01 353-01
T/C output revolution sensor 3 1 G-B L-W G-B L
352-01 351-01 354-01 353-01 SL00104 B-Y R-W
white tape
B-W W-Y G-B L 20 2 1
17 SUMITOMO MT090 SUMITOMO MT090
SUMITOMO MT090 6189-0031
SUMITOMO DL040 186-01 102-01 6189-0031
TO 6189-0031
6188-0494 W-Y L
YAZAKI SWP
CN.108
white tape 7123-1424-40 T/M forward clutch solenoid
Gray
CN.102 2 1
To rear console CN.704 352-01 351-01
F B-W W-Y
1 3
white tape white tape
122-01 125-01 121-01
B-Y G-B R-W CN.111 CN.113 SUMITOMO MT090
6189-0031
RTM2 2 1
3 1
113-01 122-01 125-01 121-01
B-W
184-01 105-01
T/M output revolution sensor POP Main pump delivery pressure sensor
SP W-Y L B-Y G-B R-W
4 6 (Machine speed sensor)
YAZAKI SWP AMP EJC2
7222-7464-40 YAZAKI SWP 174357-2
7123-1424-40
Gray
CN.109
2 1
TM
188-01 103-01 T/M intermediate shaft revolution sensor
W-Y L (machine speed backup)
YAZAKI SWP
7123-1424-40
Gray
From To
Wire Wire
Wire No.
CN/JN CN/JN Dia. Color
Pin Pin
No. No.
1 101-01 CN.114 T/C input rev. sensor (E/G speed) 1 CN.101 Rear console CN.703 1 0.85 L
2 102-01 CN.110 T/C output rev. sensor 1 CN.101 Rear console CN.703 3 0.85 L
3 103-01 CN.109 T/M intermediate shaft rev. sensor (machine speed backup) 1 CN.101 Rear console CN.703 5 0.85 L
4 105-01 CN.111 T/M output rev. sensor (machine speed) 1 CN.101 Rear console CN.703 7 0.85 L
5 113-01 CN.112 T/C oil temperature sensor 1 CN.102 Rear console CN.704 4 0.75 B-W
6 121-01 CN.113 Main pump delivery pressure sensor 1 CN.102 Rear console CN.704 3 0.75 R-W
7 122-01 CN.113 Main pump delivery pressure sensor 3 CN.102 Rear console CN.704 1 0.75 B-Y
8 125-01 CN.113 Main pump delivery pressure sensor 2 CN.102 Rear console CN.704 2 0.85 G-B
9 182-01 CN.114 T/C input rev. sensor (E/G speed) 2 CN.101 Rear console CN.703 2 0.85 W-Y
10 184-01 CN.111 T/M output rev. sensor (machine speed) 2 CN.101 Rear console CN.703 8 0.85 W-Y
11 186-01 CN.110 T/C output rev. sensor 2 CN.101 Rear console CN.703 4 0.85 W-Y
12 188-01 CN.109 T/M intermediate shaft rev. sensor (machine speed backup) 2 CN.101 Rear console CN.703 6 0.85 W-Y
13 351-01 CN.108 T/M forward clutch solenoid 1 CN.101 Rear console CN.703 18 0.85 W-Y
14 352-01 CN.108 T/M forward clutch solenoid 2 CN.101 Rear console CN.703 17 0.75 B-W
15 353-01 CN.107 T/M reverse clutch solenoid 1 CN.101 Rear console CN.703 20 0.85 L
16 354-01 CN.107 T/M reverse clutch solenoid 2 CN.101 Rear console CN.703 19 0.85 G-B
17 355-01 CN.105 T/M 1st speed clutch solenoid 1 CN.101 Rear console CN.703 10 0.85 L-W
18 356-01 CN.105 T/M 1st speed clutch solenoid 2 CN.101 Rear console CN.703 9 0.85 G-B
19 357-01 CN.104 T/M 2nd speed clutch solenoid 1 CN.101 Rear console CN.703 12 0.85 R-G
20 358-01 CN.104 T/M 2nd speed clutch solenoid 2 CN.101 Rear console CN.703 11 0.75 B-Y
21 359-01 CN.106 T/M 3rd speed clutch solenoid 1 CN.101 Rear console CN.703 14 0.75 R-W
22 360-01 CN.106 T/M 3rd speed clutch solenoid 2 CN.101 Rear console CN.703 13 0.75 B-Y
23 361-01 CN.103 T/M 4th speed clutch solenoid 1 CN.101 Rear console CN.703 16 0.85 R
24 362-01 CN.103 T/M 4th speed clutch solenoid 2 CN.101 Rear console CN.703 15 0.75 B-W
-8-
ZW310-5A Front Console Wiring Diagram (1/2)
CN.411
Monitor 1-A
10 9 8
555-01 5 7 000-25 272-01 021-05 011-05 1
W-R B W-L Y R
0.5 0.5 0.5 0.5 0.5
M-1A
CN.431 227-01 552-01 151-01 000-26 6
1 15 14 13 592-01 591-01
B-Y R-B R-L B V G-Y
Front wiper relay (Hi) CN.406 20 0.5 0.5 0.5 0.5 0.5 0.5 11
Hazard SW CN.407 AMP 040
175967-2
3 1
4 515-02 3 Working light SW
448-01 441-01 082-03 501-01 000-07 1 CN.412
P-B W G P L-R B 4 515-04 3 426-01 000-10 1 Monitor 1-B
0.5 0.85 0.5 0.5 0.5 0.5 HAZ P R-W B
000-08 9 205-01 014-01 412-01 205-01 JN.D09 JN.D11 0.5 0.5 0.5
442-01 B Gr Y-R L Gr WL 8 000-mt 7 6 514-01 543-01 542-01 554-01 556-01 1
000-11 425-03 464-03 464-02 425-02 515-05
O WRH 10 0.5 0.5 0.5 0.5 0.5 5 B Y-R P-B P-B Y-R P B Y-R Y-R V Br W-R
JN.D10 JN.D13 0.5 0.5 0.5 0.5 0.5 0.5
0.85 YAZAKI SDL-2 10 0.5 0.5 0.5 0.5 0.5 0.5 5 M-1B
4 7183-4000 15 13 11
YAZAKI SDL-2 226-01 553-01 229-01 228-01
443-01 7183-4000 G-L O Br-Y P-B
16 0.5 0.5 0.5 0.5 9
V CN.433 AMP 040
0.85
CN.432
5 Solar isolation sensor 175966-2
Front wiper relay (Lo) SUMITOMO MICRO-ISO-RELAY CN.408 2 612-01 611-01 1

6098-1493 Parking brake SW SS P W-G CN.419
3 1 CN.423 0.5 0.5 Declutch SW
447-01 444-01 082-02 4 2
000-14 000-13 1 YAZAKI 050
R-W Y G Diode (Front wiper SW) B B 7283-7623 4 218-01 217-01 218-01 000-02 1
0.5 0.85 0.5 0.5 0.5 Br-Y L-Y Br-Y B
P 0.5 0.5 0.5 0.5
2 226-01 224-01 1 9 201-01 202-01 000-15 515-03 CLU
000-28 JN.D03 Br G-O B P 000-04 267-01 021-02 000-03 268-01 217-01
G-L Br-W DFW JN.D12 B W-G Y B G-Y L-Y
B WRL 10 0.5 0.5 0.5 0.5 5
0.5 0.5 10 0.5 0.5 0.5 0.5 0.5 0.5 5
4 0.85 YAZAKI SDL-2
B JN.D08 YAZAKI 090 YAZAKI 090 YAZAKI SDL-2
000-01 7321-9822 7123-7729-40
7183-4000 CN.418 7183-4000
443-01 000-20
CN.420 Shift up delay SW
V 000-25 CN.424
5 0.85 000-26 GND Diode (Column FNR SW)
3 4 2
595-01
1
000-27 CN.425 G-R
0.5
000-28
000-29
- Buzzer
SUMITOMO MICRO-ISO-RELAY 2 1 10 9 7
SL00810 543-01 451-01 1 2 000-06 270-01 021-07
6098-1493 000-fc
000-mt Y-R P-B DNR B G-R Y CN.426
021-06 529-01 0.5 0.5 0.5 5
0.5 0.5
BZ Y L-R Cigar lighter (+24V)
0.5 0.5 YAZAKI SDL-2
YAZAKI 090 YAZAKI 090 7183-4000 1
CN.401 7321-9822 7123-7729-40 SUMITOMO MTW
087-01
W-R
To Rear Console CN.710 6030-2981 SUP CB001 0.85
To rear console
1 912-01 901-01 923-01 905-01 4 CL CN.427
W O L-Y Y-G JN.D07 JN.D06 JN.D05 JN.D04 JN.D22 white tape white tape
Cigar lighter (GND)
1.25 0.5 0.85 0.85 white tape CN.417
JN.D23 2 (YA-7120-3011)
5 426-01 425-01 014-01 907-01 8 JN.D24 Auto/manual SW 000-30
R-W Y-R Y-R L-B CN.428 B
0.5 0.5 0.5 0.85
FFA
CN.430 Joint option (A) 7116-2270 0.85
1 2 3
032-01 000-fc 515-01 202-01 Joint connector (C)
W-L B P G-O
9 0.85 2.0 0.5 0.5 12 10 8 9 021-06 021-05 021-04 021-03 021-02 021-01 1 4 1
021-07 201-01 409-01 211-01 000-01 AM
464-01 412-01 409-01 501-02 Y Y Y Y Y Y Y Br R-W G-B B 000-24 254-01 255-01
CN.402 P-B L R-W L-R 0.5 0.5 0.5 0.5 0.5 0.5 0.85 0.5 0.5 0.5 0.5 B Br-W V CN.413
To Rear Console CN.711 13 0.5 0.5 0.5 0.5 16 19 18 17 16 JCC JPA 6 0.5 0.5 0.5 4
011-05 011-04 011-03 011-02 011-01 021-04 032-01 907-01 011-04 SUMITOMO MTW Starter key SW
YAZAKI SWP
R R R R R Y W-L L-B R
0.5 0.5 0.5 0.5 0.85 0.5 0.85 0.85 0.5 6040-6111
1 S1S-00 556-01 7222-7564-40 8 5 3 2 1
554-01 542-01 4 20 11 901-01 905-01
Gr W-R Br V SUMITOMO HM090 SUMITOMO DL090 O Y-G
6195-0051
0.5 0.5 0.5 0.5 6400-0081 0.5 0.85
5
KEY 5
451-01 514-01 228-01 229-01 8 402-01 923-01 912-01
P-B Y-R P-B Br-Y CN.429 Y L-Y W
0.5 0.5 0.5 0.5 Joint option (B) CN.414 6 0.85 1.25 4
9 553-01 224-01 517-01 511-01 12 Front wiper motor YAZAKI CN
O Br-W L-W G-Y FFB 7123-2262
0.5 0.5 0.5 0.5 1 2 3 4 White
JN.D21 3 1
13 red tape 441-01 442-01
502-01 462-01 461-01 707-01 16 W O
R-L V L G-W 0.85 0.85
0.5 0.5 0.5 0.5 SUMITOMO HM090 5 6 7 8
6409-0255
WIP
082-04 444-01
153-01 154-01 S1L-01 S1H-01 G Y
Y-B Gr W L 6 0.85 0.85 4
17 0.5 0.5 0.5 0.5 20 CN.403 SUMITOMO DL090 YAZAKI CN
SUMITOMO DL040 To Rear Console CN.712 6195-0054 7123-2262
6188-0494 CN.416 906-01 White
G
1 Monitor 2-A
582-01 584-01 581-01 578-01 4
P L-R Y-G Br
0.5 0.5 0.5 0.5 10 9 8 7 529-016 2 3 1 4 CN.435
5 579-01 593-01 583-01 594-01 8 L-R CN.409 Disconnect (ICF)
Gr B-Y R-L W-G 0.5 (Information controller) ICF-C
447-01 448-01 461-01 462-01 501-03 502-01 511-01 517-01
M-2A
0.5 0.5 0.5 0.5
FFC R-W P-B L V L-R R-L G-Y L-W
S1S-03
598-01 597-01 585-01 596-01 S
R-W Y-R W-B Gr 0.5 0.5 0.5 0.5 0.5 0.5 0.5 0.5 11 1 0.5
20 011-02 011-03 3 577-01 S1H-03 6
1
9 0.5 0.5 0.5 0.5 12 AMP 040 R R Y-R L
577-01 011-01 021-01 082-01 175967-2 0.5 0.5 0.5 0.5
Y-R R Y G CN.415
1.25 16 7 021-03 707-03 000-23 10
13 0.5 0.85 0.85 Monitor 2-B Y G-W B
S1L-03
W I-C
CN.404 SUMITOMO DL090 0.5 0.5 0.5 0.5 12
To Rear Console CN.713 6188-0495 8 707-02 7 6 5 2 3 1 4 JN.D02
000-22 000-21 16
G-W
0.5 B B
1 087-01 000-sw 611-01 612-01 4 154-01 153-01 14 13 12 11 S1H-02S1L-02
M-2B 13 0.5 0.5 17
W-R B W-G P
0.85 1.25 0.5 0.5 Gr Y-B L W AMP 040-3
16 0.5 0.5 0.5 0.5 9 353027-1
White
CN.410
5 211-01 6 555-01 591-01 8
G-B W-R G-Y
AMP 040 (Information controller) ICF-A
175966-2
0.5 0.5 0.5
9 592-01 151-01 11 552-01 12 1 2 3 4 579-01 9
V R-L R-B FFD CN.434 582-01 584-01 581-01 578-01
0.5 0.5 0.5 P L-R Y-G Br Gr
HMS CN.421 Disconnect (Monitor) 0.5 0.5 0.5 0.5 0.5
13 227-01 270-01 15 595-01 16 1
B-Y G-R G-R Hour meter stop SW S1S-02 10 593-01 11 12 13 14 15 16 583-01 594-01 000-17 598-01 597-01 21
0.5 0.5 0.5 S I-A
000-27 B-Y R-L W-G B R-W Y-R
267-01 268-01 255-01 254-01 B 0.5 0.5 0.5 0.5 0.5 0.5 0.5
W-G G-Y V Br-W CA001 JN.D01
0.5 0.5 0.5 0.5 20 22 23 24 25 26 27
17
CN.422
585-01
W-B
000-18 000-19
B B
596-01
Gr
-9-
SUMITOMO DL040
6188-0494 Hour meter stop SW 0.5 29 0.5 0.5 0.5 31
33194-48700A
272-01 AMP 040-3
W-L 353031-1
CB001 White
ZW310-5A Front Console Wiring Diagram (2/2)
From To Wire From To Wire
Wire Wire No. Wire
Wire No. Color Color
Dia. CN/JN No. Pin CN/JN No. Pin Dia.
CN/JN No. Pin CN/JN No. Pin
1 000-01 CN.428 Joint option (A) 1 CN.420 GND 1 0.5 B 75 412-01 CN.406 Hazard SW 6 CN.401 Rear console CN.710 14 0.5 L
2 000-02 CN.419 Declutch SW 1 JN.D12 0.5 B 76 425-01 JN.D10 CN.401 Rear console CN.710 6 0.5 Y-R
3 000-03 CN.419 Declutch SW 7 JN.D12 0.5 B 77 425-02 CN.407 Working light SW 6 JN.D10 0.5 Y-R
4 000-04 JN.D12 CN.419 Declutch SW 10 0.5 B 78 425-03 JN.D10 CN.407 Working light SW 9 0.5 Y-R
5 000-05 JN.D12 JN.D04 0.5 B 79 426-01 CN.407 Working light SW 2 CN.401 Rear console CN.710 5 0.5 R-W
6 000-06 CN.418 Shift up delay SW 8 JN.D04 0.5 B 80 441-01 CN.414 Front wiper motor 2 CN.431 Front wiper relay (HI) 2 0.85 W
7 000-07 CN.406 Hazard SW 1 JN.D09 0.5 B 81 442-01 CN.414 Front wiper motor 1 CN.431 Front wiper relay (HI) 4 0.85 O
8 000-08 CN.406 Hazard SW 10 JN.D09 0.5 B 82 443-01 CN.431 Front wiper relay (HI) 5 CN.432 Front wiper relay (LO) 5 0.85 V
9 000-09 JN.D09 JN.D04 0.5 B 83 444-01 CN.414 Front wiper motor 4 CN.432 Front wiper relay (LO) 2 0.85 Y
10 000-10 CN.407 Working light SW 1 JN.D11 0.5 B 84 447-01 CN.416 Monitor 2-A 19 CN.432 Front wiper relay (LO) 3 0.5 R-W
11 000-11 JN.D11 CN.407 Working light SW 10 0.5 B 85 448-01 CN.416 Monitor 2-A 18 CN.431 Front wiper relay (HI) 3 0.5 P-B
12 000-12 JN.D11 JN.D04 0.5 B 86 451-01 CN.402 Rear console CN.711 5 CN.424 Diode (FNR SW) 1 0.5 P-B
13 000-13 CN.408 Parking brake SW 1 JN.D03 0.5 B 87 461-01 CN.402 Rear console CN.711 15 CN.416 Monitor 2-A 17 0.5 L
14 000-14 CN.408 Parking brake SW 3 JN.D03 0.5 B 88 462-01 CN.402 Rear console CN.711 14 CN.416 Monitor 2-A 16 0.5 V
15 000-15 JN.D03 CN.408 Parking brake SW 6 0.5 B 89 464-01 JN.D13 CN.401 Rear console CN.710 13 0.5 P-B
16 000-16 JN.D03 JN.D04 0.5 B 90 464-02 CN.407 Working light SW 7 JN.D13 0.5 P-B
17 000-17 JN.D01 CN.410 ICF-A 19 0.5 B 91 464-03 JN.D13 CN.407 Working light SW 8 0.5 P-B
18 000-18 CN.410 ICF-A 29 JN.D01 0.5 B 92 501-01 JN.D07 CN.406 Hazard SW 2 0.5 L-R
19 000-19 CN.410 ICF-A 30 JN.D01 0.5 B 93 501-02 JN.D07 CN.401 Rear console CN.710 16 0.5 L-R
20 000-20 JN.D01 CN.420 GND 1 0.5 B 94 501-03 JN.D07 CN.416 Monitor 2-A 15 0.5 L-R
21 000-21 CN.409 ICF-C 15 JN.D02 0.5 B 95 502-01 CN.402 Rear console CN.711 13 CN.416 Monitor 2-A 14 0.5 R-L
22 000-22 JN.D02 CN.409 ICF-C 14 0.5 B 96 511-01 CN.402 Rear console CN.711 12 CN.416 Monitor 2-A 13 0.5 G-Y
23 000-23 JN.D02 CN.409 ICF-C 9 0.5 B 97 514-01 CN.402 Rear console CN.711 6 CN.412 Monitor 1-B 5 0.5 Y-R
24 000-24 JN.D04 CN.417 Auto/manual SW 6 0.5 B 98 515-01 JN.D05 CN.401 Rear console CN.710 11 0.5 P
25 000-25 CN.411 Monitor 1-A 4 CN.420 GND 1 0.5 B 99 515-02 CN.406 Hazard SW 4 JN.D05 0.5 P
26 000-26 CN.411 Monitor 1-A 17 CN.420 GND 1 0.5 B 100 515-03 CN.408 Parking brake SW 5 JN.D05 0.5 P
27 000-27 CN.421 Hour meter stop SW 1 CN.420 GND 1 0.5 B 101 515-04 CN.407 Working light SW 4 JN.D05 0.5 P
28 000-28 CN.432 Front wiper relay (LO) 4 CN.420 GND 1 0.85 B 102 515-05 CN.407 Working light SW 5 JN.D05 0.5 P
29 000-29 JN.D02 CN.420 GND 1 0.5 B 103 517-01 CN.402 Rear console CN.711 11 CN.416 Monitor 2-A 12 0.5 L-W
30 000-30 CN.427 Cigar lighter (GND) 1 JN.D04 0.85 B 104 529-01 CN.416 Monitor 2-A 5 CN.425 Buzzer 2 0.5 L-R
31 000-fc CN.420 GND 1 CN.401 Rear console CN.710 10 2.0 B 105 542-01 CN.402 Rear console CN.711 4 CN.412 Monitor 1-B 3 0.5 V
32 000-mt CN.412 Monitor 1-B 8 CN.420 GND 1 0.5 B 106 543-01 CN.412 Monitor 1-B 4 CN.424 Diode (FNR SW) 2 0.5 Y-R
33 000-sw JN.D04 CN.404 Rear console CN.713 2 1.25 B 107 552-01 CN.404 Rear console CN.713 12 CN.411 Monitor 1-A 19 0.5 R-B
34 011-01 CN.430 Joint connector (C) 11 CN.403 Rear console CN.712 14 0.85 R 108 553-01 CN.402 Rear console CN.711 9 CN.412 Monitor 1-B 12 0.5 O
35 011-02 CN.430 Joint connector (C) 12 CN.409 ICF-C 1 0.5 R 109 554-01 CN.402 Rear console CN.711 3 CN.412 Monitor 1-B 2 0.5 Br
36 011-03 CN.430 Joint connector (C) 13 CN.409 ICF-C 2 0.5 R 110 555-01 CN.404 Rear console CN.713 7 CN.411 Monitor 1-A 6 0.5 W-R
37 011-04 CN.430 Joint connector (C) 14 CN.428 Joint option (A) 5 0.5 R 111 556-01 CN.402 Rear console CN.711 2 CN.412 Monitor 1-B 1 0.5 W-R
38 011-05 CN.430 Joint connector (C) 15 CN.411 Monitor 1-A 1 0.5 R 112 577-01 CN.409 ICF-C 4 CN.403 Rear console CN.712 13 0.5 Y-R
39 014-01 CN.406 Hazard SW 7 CN.401 Rear console CN.710 7 0.5 Y-R 113 578-01 CN.410 ICF-A 8 CN.403 Rear console CN.712 4 0.5 Br
40 021-01 CN.430 Joint connector (C) 1 CN.403 Rear console CN.712 15 0.85 Y 114 579-01 CN.410 ICF-A 9 CN.403 Rear console CN.712 5 0.5 Gr
41 021-02 CN.419 Declutch SW 8 CN.430 Joint connector (C) 2 0.5 Y 115 581-01 CN.410 ICF-A 7 CN.403 Rear console CN.712 3 0.5 Y-G
42 021-03 CN.430 Joint connector (C) 3 CN.409 ICF-C 7 0.5 Y 116 582-01 CN.410 ICF-A 5 CN.403 Rear console CN.712 1 0.5 P
43 021-04 CN.430 Joint connector (C) 4 CN.428 Joint option (A) 8 0.5 Y 117 583-01 CN.410 ICF-A 17 CN.403 Rear console CN.712 7 0.5 R-L
44 021-05 CN.430 Joint connector (C) 5 CN.411 Monitor 1-A 2 0.5 Y 118 584-01 CN.410 ICF-A 6 CN.403 Rear console CN.712 2 0.5 L-R
45 021-06 CN.430 Joint connector (C) 6 CN.425 Buzzer 1 0.5 Y 119 585-01 CN.410 ICF-A 28 CN.403 Rear console CN.712 11 0.5 W-B
46 021-07 CN.418 Shift up delay SW 5 CN.430 Joint connector (C) 7 0.5 Y 120 591-01 CN.404 Rear console CN.713 8 CN.411 Monitor 1-A 11 0.5 G-Y
47 032-01 CN.428 Joint option (A) 7 CN.401 Rear console CN.710 9 0.85 W-L 121 592-01 CN.404 Rear console CN.713 9 CN.411 Monitor 1-A 12 0.5 V
48 082-01 JN.D08 CN.403 Rear console CN.712 16 1.25 G 122 593-01 CN.410 ICF-A 10 CN.403 Rear console CN.712 6 0.5 B-Y
49 082-02 CN.432 Front wiper relay (LO) 1 JN.D08 0.5 G 123 594-01 CN.410 ICF-A 18 CN.403 Rear console CN.712 8 0.5 W-G
50 082-03 JN.D08 CN.431 Front wiper relay (HI) 1 0.5 G 124 595-01 CN.418 Shift up delay SW 1 CN.404 Rear console CN.713 16 0.5 G-R
51 082-04 CN.414 Front wiper motor 5 JN.D08 0.85 G 125 596-01 CN.410 ICF-A 31 CN.403 Rear console CN.712 12 0.5 Gr
52 087-01 CN.426 Cigar lighter (+24V) 1 CN.404 Rear console CN.713 1 0.85 W-R 126 597-01 CN.410 ICF-A 21 CN.403 Rear console CN.712 10 0.5 Y-R
53 151-01 CN.404 Rear console CN.713 10 CN.411 Monitor 1-A 18 0.5 R-L 127 598-01 CN.410 ICF-A 20 CN.403 Rear console CN.712 9 0.5 R-W
54 153-01 CN.402 Rear console CN.711 17 CN.415 Monitor 2-B 15 0.5 Y-B 128 611-01 CN.433 Solar isolation sensor 1 CN.404 Rear console CN.713 3 0.5 W-G
55 154-01 CN.402 Rear console CN.711 18 CN.415 Monitor 2-B 16 0.5 Gr 129 612-01 CN.433 Solar isolation sensor 2 CN.404 Rear console CN.713 4 0.5 P
56 201-01 CN.408 Parking brake SW 8 CN.428 Joint option (A) 4 0.5 Br 130 707-01 JN.D06 CN.402 Rear console CN.711 16 0.5 G-W
57 202-01 CN.408 Parking brake SW 7 CN.401 Rear console CN.710 12 0.5 G-O 131 707-02 CN.415 Monitor 2-B 8 JN.D06 0.5 G-W
58 205-01 CN.406 Hazard SW 8 CN.406 Hazard SW 5 0.5 Gr 132 707-03 JN.D06 CN.409 ICF-C 8 0.5 G-W
59 211-01 CN.428 Joint option (A) 2 CN.404 Rear console CN.713 5 0.5 G-B 133 901-01 CN.413 Starter key SW 3 CN.401 Rear console CN.710 2 0.5 O
60 217-01 CN.419 Declutch SW 5 CN.419 Declutch SW 3 0.5 L-Y 134 905-01 CN.413 Starter key SW 1 CN.401 Rear console CN.710 4 0.85 Y-G
61 218-01 CN.419 Declutch SW 4 CN.419 Declutch SW 2 0.5 Br-Y 135 906-01 CN.429 Joint option (B) 6 CN.429 Joint option (B) 7 0.85 G
62 224-01 CN.402 Rear console CN.711 10 CN.423 Diode (Front wiper SW) 1 0.5 Br-W 136 907-01 CN.428 Joint option (A) 6 CN.401 Rear console CN.710 8 0.85 L-B
63 226-01 CN.412 Monitor 1-B 14 CN.423 Diode (Front wiper SW) 2 0.5 G-L 137 912-01 CN.413 Starter key SW 4 CN.401 Rear console CN.710 1 1.25
64 227-01 CN.404 Rear console CN.713 13 CN.411 Monitor 1-A 20 0.5 B-Y 138 923-01 CN.413 Starter key SW 6 CN.401 Rear console CN.710 3 0.85 L-Y
65 228-01 CN.402 Rear console CN.711 7 CN.412 Monitor 1-B 9 0.5 P-B 139 S1H-01 JN.D22 CN.402 Rear console CN.711 20 0.5 L
66 229-01 CN.402 Rear console CN.711 8 CN.412 Monitor 1-B 10 0.5 Br-Y 140 S1H-02 CN.415 Monitor 2-B 10 JN.D22 0.5 L
67 254-01 CN.404 Rear console CN.713 20 CN.417 Auto/manual SW 5 0.5 Br-W 141 S1H-03 JN.D22 CN.409 ICF-C 5 0.5 L
68 255-01 CN.404 Rear console CN.713 19 CN.417 Auto/manual SW 4 0.5 V 142 S1L-01 JN.D23 CN.402 Rear console CN.711 19 0.5 W
69 267-01 CN.419 Declutch SW 9 CN.404 Rear console CN.713 17 0.5 W-G 143 S1L-02 CN.415 Monitor 2-B 9 JN.D23 0.5 W
70 268-01 CN.419 Declutch SW 6 CN.404 Rear console CN.713 18 0.5 G-Y 144 S1L-03 CN.409 ICF-C 11 JN.D23 0.5 W
71 270-01 CN.418 Shift up delay SW 6 CN.404 Rear console CN.713 14 0.5 G-R 145 S1S-00 CN.402 Rear console CN.711 1 JN.D21 0.5 Gr
- 10 - 72 272-01 CN.411 Monitor 1-A 3 CN.422 Hour meter stop SW 1 0.5 W-L 146 S1S-01 JN.D21 JN.D24 0.5 S
73 402-01 CN.429 Joint option (B) 3 CN.429 Joint option (B) 4 0.5 Y 147 S1S-02 JN.D24 CN.434 Disconnect (Monitor) 1 0.5 S 33194-48700A
74 409-01 CN.428 Joint option (A) 3 CN.401 Rear console CN.710 15 0.5 R-W 148 S1S-03 JN.D24 CN.435 Disconnect (ICF) 1 0.5 S
ZW310-5A Floor Wiring Diagram (Rear Console) (1/5) CN.731
To wiper/horn SW
To A/C panel cable
CN.783 CN.756
CN.754 Diode unit (hazard1) A/C operation panel (A)
Flasher unit To floor rear console (2/5) (p.19) 3 1
4 211-02 227-01 229-01 228-01 1
G-B B-Y Br-Y P-B
413-01 415-01 412-02 4 612-01 611-01 605-01 021-13 1
CN.735 2 1 CN.804 DTR
0.5 0.5 0.5 0.5
P W-G L-W Y
000-fls R-W P-W L HWS
B For option SW (not used) 0.5 0.5 0.5 0.5 0.5 0.5 0.5
Optional power supply (ACC1) 0.85 224-03 000-wip 231-01 232-01 8
619-01 618-01 616-01 615-01
5
014-03 411-01
FL 840-01
YAZAKI 090 YAZAKI 090 Br-W B R-W L-Y
ACA P-B B-Y G-R Y
1 OPS 7321-9834-30 7123-9135-50 8 0.5 0.5 0.5 0.5 5
CN.738 808-02 Y-R Br-Y CB001
Y-G
0.5 To side console1 0.5 0.5 0.5 0.5
Optional power W-R ACC1 4 0.85 0.85 3 YAZAKI 62Z 623-01 622-01 621-01 620-01
2.0 YAZAKI CN CN.784 7123-7780-40 O Gr G-R Y-R
supply (ACC2) YAZAKI CN 7123-2446 CN.715 Diode unit (hazard2) 12 0.5 0.5 0.5 0.5 9
1
7123-2215-90 White To side console 1 CN.501 3 1 CN.780 SUMITOMO DL090
812-01 Blue Column shift lever (T/M) 6195-0149
W-B ACC2 412-03 416-01 414-01
1.25 CN.736 CN.803 4 295-01 294-01 293-01 000-sc1 1
L W-R L-Y DTL CN.716
YAZAKI CN
Optional power
0.5 0.5 0.5 4 1 Disconnect CN.753
Optional power L-B W-G Gr-L B 241-01 242-01 243-01 000-cs2
7123-2215-90
Blue supply (Bt) supply (ACC3) 0.5 0.5 0.5 0.85 YAZAKI 090
7321-9834-30
YAZAKI 090
7123-9135-50
W-R L-Y G-W B (A/C panel) A/C operation panel (B)
8
259-01 249-01 252-01 296-01 5 0.5 0.5 0.5 0.5
TM 1
CN.740 1
802-01 1 813-01
P-W
0.5
Br
0.5
W-L
0.5
W-Y
0.5 To side console2 247-01 248-01 000-cs3 5 S1S-12 4 627-01 626-01 625-01 624-01 1
JN.G61 S
Option GND P W-L ACC3 12 342-01 081-03 506-01 505-03 9
L-Y
0.5
Br-Y
0.5
B
0.5 0.5 W-R B-R W-B B-L
(ACC1) 2.0
BT
0.85 RS1 G-B Y-G W-G Br-W CN.717 8 5 0.5 0.5 0.5 0.5
YAZAKI CN YAZAKI CN 0.5 0.5 0.5 0.5 YAZAKI SWP
7123-2215-80 Blue To side console 2 CN.601 631-01 630-01 629-01 628-01
1 Brown
7123-2215-90 16
515-04 257-01
14
341-01
13 7123-7484-40
ACB L-B Br-Y G-W Lg
000-op1
B
P L-Y L-R CN.782 8 0.5 0.5 0.5 0.5 5
2.0 GND1 0.5 0.5 0.5
4 1 Column shift lever (lighting) S1L-12 S1H-12 000-ap
CN.741 253-01
19 18
251-01
17 081-02 3 432-01 000-sc5 W L B
YAZAKI CN Y-G Br-Y B 12 0.5 0.5 0.5 9
L-B Gr
7122-2115-30 0.5 0.5 0.5
1 000-op2 20 0.5 0.5 3 1
Black Option GND 8 235-01 000-sc3 211-04 5
422-01 421-01 514-02 YAZAKI SWP
(ACC2) B GND2 white tape SUMITOMO DL040
G-R B G-B
Gr R-Y Y-R 7123-7923-40
1.25 6189-0714 0.5 0.5 0.5
CN.762 0.5 0.5 0.5 LT
JN.G31 JN.G32 JN.G33

YAZAKI CN RS3 016-01
4 5
Option GND (ACC3) 7122-2115-30 CN.763 JN.G62
236-01 536-01 244-01 535-01
P-W L-Y W-L Br-Y
Br To front console
Black 6 0.85
CN.727 12 0.5 0.5 0.5 0.5 9
1 000-op3 1
000-bt To side console 4 431-01 258-01 14 246-01 YAZAKI SWP CN.710
Option GND (Bt) B GNDB W-R R-Y Y-B
CN.781 7123-7464-40
GND3 To front console CN.401
white tape
B
2.0 16 0.5 0.5 0.5 13
0.85
YAZAKI CN 2 1 Column shift lever (turn)
YAZAKI CN 7122-2115-30 000-sc4 305-01 YAZAKI SWP
7122-2115-30
Black B R-Y 7123-7564-40 4 905-01 923-01 901-01 912-02 1
Black 0.5 0.5 2 1
062-05 413-01 Y-G L-Y O W
222-01 515-05 RS4 CN.702 L-B R-W 0.85 0.85 0.5 1.25
CN.734
CAB Connectors CAB-A
G-R
0.5
P
0.5
Control lever pilot primary pressure sensor TRN
0.5
414-01 3
0.5 8
907-01 014-02 425-01 426-01
L-B Y-R Y-R R-W
5
4 3
JN.H10 JN.G22 L-Y 0.85 0.5 0.5 0.5
JN.G48 YAZAKI SWP YAZAKI SWP FFA
3 083-06 446-01 017-01 1 JN.H11 3 1 4 0.5
JN.G49 7222-7444-40 7123-7444-40 121-01 128-01 122-06 202-01 515-03 000-fc 032-01
W-R R-G L-W JN.H12 PS P Y V G-O P B W-L
YAZAKI SWP
0.85 0.85 0.85 12 0.5 0.5 2.0 0.85 9
CN.768 6 001-01 445-01
CAB-A
Black
0.5 0.5 0.5
JN.H17
7123-7444-40
501-02 409-02 412-01 514-04
CAB-B G-R V JN. JN. white tape
YAZAKI 91-RV
7223-6536-30 white tape JN.H18 L-R R-W L Y-R
0.5 0.85 4 G53 G38 JN.G35 JN.H19 16 0.5 0.5 0.5 0.5 13
2 1 YAZAKI CN
517-02 YAZAKI SWP
7123-2262 JN.G46 JN.G18 JN.G26 JN.G23 JN.G20
L-W
White JN.G29 CN.794
JN.G19
CN.728
JN.G11 CN.701 7123-7564-40
0.85
000-cab 091-01 CAB-B
JN.G41
A/C gas pressure sensor Throttle pedal Service brake secondary pressure sensor (CC)
JN.G08
B L CN.766 1 CN.711
3.0 1.25 3 3
4
YAZAKI CN
CAB-F 3 1
123-02 138-01 124-02
To front console CN.402
1 6
JN.G34
124-04 129-01 123-04 134-01

7123-2446
CN.732 ACG G-B P W P-B
SBC W G-Y G-B
White 1
519-01 0.5 0.5 0.5 0.5 0.5 0.5 4 1
0.5
CAB-R YAZAKI CN W-B CAB-F CN.789 2 5 YAZAKI 91-RV
542-01 554-02
V Br
556-01 S1S-99
W-R Gr
122-04
7123-2215
0.85
A/C gas Hi/Lo pressure SW ACL V 7223-6536-30 CN.767 0.5 0.5 0.5 0.5
1 520-01 White SUMITOMO TS 0.5 Black Brake lamp SW 8
229-01 228-01 514-03 451-05
5
6189-0099
white tape
White
G CAB-R 4 Br-Y P-B Y-R P-B
121-02
0.85 2 1 P 0.5 0.5 0.5 0.5
YAZAKI CN 000-acp 605-01
12 9
7123-2215 ACP B L-W 3 0.5
BLS A 062-02 206-01 B 511-03 517-03 224-01 553-01
0.5 0.5 SUMITOMO TS
L-B Br-W FFB G-Y L-W Br-W O
CN.749 6189-0094 DEUTSCH DT
DT06-6S-CE05
CN.788 0.5 0.5
JN.H20 red tape
0.5 0.5 0.5 0.5
Axle oil cooler relay (opt) Emergency throttle 000-bls 707-03 461-01 462-01 502-02
B G-W L V R-L
CN.704 0.5 16 0.5 0.5 0.5 0.5 13
1
456-01 To transmission To T/M CN.102 1 6 C S1H-13 S1L-13 154-01 153-01
Br 716-01 L W Gr Y-B
W
OAX
0.5
CN.703 0.5 DEUTSCH DT 20 0.5 0.5 0.5 0.5 17
YAZAKI CN YAZAKI CN 1
7123-2215 7122-2215
3
121-03 125-01 122-03 To T/M CN.101 2
717-01
5 DT06-3S-CE05 SUMITOMO DL040
6189-0714
White White P G V EMG B
CN.750 0.5 0.5 0.5 0.5
RTM2 4 186-01 102-01 182-01 101-01 1 4
GPS/GSM unit red tape
5 6
113-01
B-W Y-B L-W W-B Y-L
715-01
R MAT
4 0.5 0.5 0.5 0.5
0.5 4 3 0.5
7 579-01 578-01 593-01 577-01 707-02 021-09 011-03 1 8 184-01 105-01 188-01 103-01 5 CN.765 CN.764
Gr Br B-Y Y-R G-W Y R YAZAKI SWP G-B L-Y L-B W-R DEUTSCH DT DEUTSCH DT
0.5 0.5 0.5 0.5 0.5 0.5 0.5 7123-7464-40 0.5 0.5 0.5 0.5 DT06-6S-CE05 DT04-6P-CE03 MAINTENANCE
GSM
597-01 598-01 596-01 13 12 11 10 9 000-gps 12 357-01 358-01 355-01 356-01 9 (E/G fault lamp) (short-circuit)
Y-R R-W Gr B JN.G09
RTM1 R-L B-Y L-W G-W CN.746
16 0.5 0.5 0.5
7123-7960
0.5 8 CN.718 0.5 0.5 0.5 0.5
Themistor assy 1
YAZAKI 62C JN.H05 16 361-01 1
1 JN.H06 362-01 359-01 360-01 13 (atmospheric temperature A/C) 554-03
Disconnect S1S-04
S
JN.H07
CN.706
R
0.5
B-R
0.5
R-W
0.5
B-L
0.5
Br
0.5 CN.712
2 1
(rear view monitor) 0.5
To rear chassis CN.202 353-01 354-01 351-01 352-01 616-03 615-01 CN.726 2
472-01
To front console CN.403
CN.729 L G-B W B-W TS G-R Y Themistor assy 724-01
B
0.5
20 0.5 0.5 0.5 0.5 17 0.5 0.5
Rear view monitor CN.747 (atmospheric temperature MC) Y-B
CN.719 4 121-04 122-02 342-01 341-01 1 SUMITOMO DL040 YAZAKI 090-2 2 0.5 4
578-01 581-01 584-01 582-01
1
1
To rear (70A fusible link) P V G-B L-R 6189-0714 7283-7028-30 1 YAZAKI CN YAZAKI CN
Br Y-G L-R P
4 5 0.5 0.5 0.5 0.5 2 0.5 0.5 0.5 0.5
Disconnect S1S-02
S 8 139-01 135-01 123-03 131-01 5
124-05 143-01 7123-2228
White
7122-2228
White 8
594-01 583-01 593-01 579-01
5
(opt CAN) 0.5 1
912-04 Gr Y W R-L
TSM G-B L-R
W-G R-L B-Y Gr
0.5 0.5
6 S1H-04
3 W RRC 0.5 0.5 0.5 0.5 red tape 0.5 0.5 0.5 0.5
8.0 RRB YAZAKI 090-2
L
0.5
327-01 142-01 126-01 127-01 CN.705 7283-7028-30 FFC 596-01 585-01 597-01 598-01
Y-R W-L Y-B R-L Gr W-B Y-R R-W
BM YAZAKI 58Y
7222-4210-40 12 0.5 0.5 0.5 0.5 9 To rear chassis CN.201 12 0.5 0.5 0.5 0.5 9
S1L-04 000-bm
W B Gray 525-01 332-01 331-01 328-01 CN.785 CN.713 082-02 021-02 011-04 577-01
7 0.5 0.5 2 CN.708 L-R W-B Y-B G-Y GND (A) G Y R Y-R
8
808-03 To rear CN.204 16 0.5 0.5 0.5 0.5 13 1 701-01 151-01 506-01 505-01 501-03 502-03 503-01 515-02 8 To front console CN.404 16 1.25 0.85 0.85 0.5 13
W-R W-B R-L W-G Br-W L-R R-L W-R P
SUMITOMO DL090
0.5 1 YAZAKI SWP 0.5 0.5 0.5 0.5 0.85 0.85 0.5 0.5 SL00810 6189-0715
1 2 7123-7564-40 9 4 612-04 611-01 000-sw 087-01 1
CN.725 965c-01 965d-01 518-01 325-01 326-01 137-01 711-03 713-01 021-08 S1H-01 S1L-01 S1S-01 18 CN.786 P W-G B W-R
DEUTSCH DT DEUTSCH DT R R RRD G-W W-B B-R Br-Y R-W L-W Y L W Gr
DT04-8PA-CE01 DT06-8SA-CE05 CAN (Opt) 8.0 8.0 19 0.85 0.5 0.5 0.5 0.85 0.85 0.5 0.5 0.5 0.5 GND (B) 8 591-01
0.5 0.5 1.25 0.85
5
715-01 716-01 717-01 712-01 770-01 769-02 512-01 215-01 555-01 6 211-03
4 YAZAKI 58Y 25 26 G-Y W-R G-B
1 7222-4220-40 R W 21 B W-R R-Y R Y-B L-R
Gray SL00810 0.5 0.5 0.5
2 3 0.5 0.5 0.5 0.5 0.5 0.5 0.85 0.5
S1H-02
CN.709 RRA 552-01 11 151-01 592-01 9
L 718-01 511-01 124-03 721-01 141-01 840-01 556-01 554-01 CN.787
0.5 To rear CN.205 JN.H02
JN.H03
JN.H01 Lg-R G-Y 29 G-B W-B Br Y-G
33
W-R Br
34
- GND (C)
FFD
12 0.5
R-B R-L
0.5
V
0.5
CAN JN.H04 27
0.5 0.85 0.5 0.5 0.5 0.5 0.5 0.5
16 595-01 15 270-01 227-01
6 7 2 724-01 136-01 591-01 592-01 531-01 532-01 321-01 322-01 061-01 407-01 44
S1L-02 1 Y-B L-W G-Y V W-L R-B R-Y L-Y B-W P G-R G-R B-Y
W 965a-01 965b-01 SL00810 0.5 0.5 0.5 13
0.5 R R RRE 35 0.5 0.5 0.5 0.5 0.85 0.85 0.5 0.5 0.5 0.5
33194-48790A
8 5
8.0 8.0 153-01 154-01 601-01 704-01 707-01 799-01 527-01 208-01 CN.778 254-01 255-01
Br-W V
268-01 267-01
G-Y W-G - 11 -
YAZAKI 62Z YAZAKI 62Z Y-B Gr G R-G G-W W-L W-B R-G
7222-7780-40 7123-7780-40
YAZAKI 58Y
7222-4220-30 45 0.5 0.5 1.25 0.85 0.85 0.5 0.85 0.5 52 GND (D) 20 0.5 0.5 0.5 0.5 17
Black SUMITOMO DL040

To rear chassis main YAZAKI SWP
7283-5055-40 SL00810 6189-0714
MCZ(E)
CN.797
MCZ(F) 1 2 5 6
3 4
000-mc5 000-mc6 011-07 011-08
B B 267-01 021-10 R R
1 2 3 4 5 6 W-G Y
0.85 0.85 0.85 0.85
065-02 065-03 065-04 000-mc2 000-mc3 000-mc4 0.5 0.5
R-L R-L R-L B B B 7 182-01 184-01 186-01 188-01 268-01 299-01 262-01 261-01 263-01 247-01
0.85 0.85 0.85 0.85 0.85 0.85 W-B G-B Y-B L-B G-Y P-B Y-G R-L W-L L-Y
JN.G06 0.5 0.5 0.5 0.5 0.5 0.5 0.5 0.5 0.5 0.5 16
7 252-01 259-01 137-01 251-01 258-01 12 293-01 294-01 15 122-01 124-01 M-F M-E 101-01 105-01 102-01 103-01 11 12 248-01 235-01 236-01 298-01
W-L P-W Br-Y Gr R-Y Gr-L W-G V G-B
JN.G07 Y-L L-Y L-W W-R Br-Y G-R P-W G-W
0.5 0.5 0.5 0.5 0.5 0.5 0.5 0.5 0.5 17
17 0.5 0.5 0.5 0.5 20 21 0.5 0.5 0.5 0.5 24
295-01 296-01 20 257-01 255-01 254-01 24 121-06 123-01
L-B W-Y L-Y V Br-W P W CN.714 AMP 025/090
0.5 0.5 0.5 0.5 0.5 0.5 0.5 1318756-1
18 26 Disconnect (MCZ1) White CN.767
AMP 025/090
1318757-1
White CN.793 S1S-06
S
3
451-01 241-01 261-01
1
1
MCZ(D) 0.5 DCF P-B W-R R-L Diode unit (column-F)
0.5 0.5 0.5
YAZAKI 090 YAZAKI 090
1 2 3 8 9 10 7123-9135-50 7321-9834-30
S1H-06S1L-06 4 5 6 7 135-01 139-01
L W Y Gr CN.779
0.5 0.5 0.5 0.5
11 249-01 278-01 279-01 134-01 127-01 126-01 138-01 129-01 136-01 20 21 22 M-D 2 1
262-01 242-01
Br O Br-W P-B R-L Y-B G-Y P L-W
0.5 0.5 0.5 0.5 0.5 0.5 0.5 0.5 0.5 DCN Y-G L-Y Diode unit (column-N)
0.5 0.5
253-01 270-01 25 26 27 128-01 29 30
AMP 025/090
L-B G-R Y 1318758-1 YAZAKI 090 YAZAKI 090
0.5 0.5 0.5 7123-7729-40 7321-9822
White
CN.799 23 CN.770
MCZ(C)
3 1
451-02 243-01 263-01
1 142-01 113-01 535-01 536-01 595-01 553-01 6 DCR P-B G-W W-L Diode unit (column-R)
W-L B-W Br-Y L-Y G-R O 0.5 0.5 0.5
0.5 0.5 0.5 0.5 0.5 0.5 YAZAKI 090 YAZAKI 090
white tape 7123-9135-50 7321-9834-30
7 141-01 143-01 552-01 555-01 455-01 456-01 12
Br L-R R-B W-R R-W Br
0.5 0.5 0.5 0.5 0.5 0.5 M-C
JN.G52 JN.G54
125-01 131-01 15 16 405-01
G R-L L-B
CN.798
13 0.5 0.5 0.5 17 CN.772
AMP 040-3 MCZ(A)
353027-1
4 3 1
White 451-04 246-01 279-01
1 356-01
G-W
355-01
L-W
361-01
R
362-01
B-R
6 7 357-01 358-01 9
R-L B-Y
DMR P-B Y-B Br-W Diode unit (opt-R)
0.5 0.5 0.5
0.5 0.5 0.5 0.5 0.5 0.5
7321-9834-30
360-01 359-01 351-01 352-01 354-01 353-01 321-01 322-01 328-01 327-01 20 21 7123-9135-50
B-L R-W W B-W G-B L R-Y L-Y G-Y Y-R M-A
10 0.5 0.5 0.5 0.5 0.5 0.5 0.5 0.5 0.5 0.5
15 CN.771
22 23 332-01 331-01 26 27 28 29 30 31
W-B Y-B 3 1
0.5 0.5 451-03 244-01 278-01
DMF P-B W-L O Diode unit (opt-F)
CN.755 AMP 040-3
353031-1
0.5 0.5 0.5
MCZ(B) White YAZAKI 090 YAZAKI 090
To floor rear console

7123-9135-50 7321-9834-30
(3/5)
1 2 3 4 5 6 7
CN.723
8 9 10 11 12 13 14 326-01 325-01 Diode unit (key ON power)
B-R W-B M-B CN.721
0.5 0.5 16 2 1 Joint connector (A)
542-01 18 19 20 21 22 23 24 CN.730 021-06 701-02 6 3
To DC-DC converter (opt) Y W-B DBR2 1
V 10 9 121-04 121-03 121-02 121-05 011-04 011-03 011-02 011-05
17 0.5 0.5
0.5 P P P P R R R R
YAZAKI 090 YAZAKI 090 0.5 0.5 0.5 0.5 0.85 0.5 0.85 0.85
AMP 040-3
353029-1
2 088-01 000-dc 1 7321-9822 7123-7729-40 JCA 20 19 122-04 122-03 122-02 122-05 707-04 707-03 707-02 707-01
W-B B
White 0.85 0.85
V V V V G-W G-W G-W G-W
DC 0.5 0.5 0.5 0.5 0.5 0.5 0.5 0.85
538-01 539-01
CN.744 W G-L 17 SUMITOMO HM090 13 11
Air conditioner (2) 4 0.85 0.85 3 6400-0015
YAZAKI 58M YAZAKI 58M
7123-6040 7122-6040
4 612-03 3 2 616-04 1
P G-R
10
0.5 0.5
AC2 CN.790
5 6 7 8
601-01
G
Air suspension seat power (opt) CN.745
CN.743 1.25
Diode unit (alternator)
Air conditioner (1) YAZAKI 090-2
7283-1100
089-01
L-R
1
SUMITOMO HM090
2.0 2 1 6409-0074
2 000-ac2 085-01 1 SEAT 707-04 701-05
B L-R 000-sh
B
G-W W-B DBR3 CN.724
2.0 2.0
AC1 2.0 2 0.5 0.5 Joint connector (B)
084-01 021-15 YAZAKI 090 YAZAKI 090 6 3
Gr Y AMP 250 AMP 250 7321-9822 7123-7729-40
4 1.25 0.5 3 180907-5 180908-5 10 021-10 021-09 021-08 021-07 021-06 021-05 021-04 021-03 021-02 021-01 1
Black Black Y Y Y Y Y Y Y Y Y Y
SUMITOMO TS
6098-0514 0.5 0.5 0.5 0.5 0.5 0.5 0.5 0.5 0.85 0.85
JCB 081-05 081-04 081-03 081-02 081-01 515-05 515-04 515-03 515-02 515-01
CN.751 Y-G Y-G Y-G Y-G Y-G P P P P P
Air conditioner (3) 0.5 0.5 0.5 0.5 0.85 0.5 0.5 0.5 0.5 0.85
20 11
17 SUMITOMO HM090 13
16 623-01 624-01 626-01 627-01 12 11 10 630-01 631-01 612-02 619-01 618-01 1 2 3 4 6440-0129
O B-L B-R W-R Br-Y L-B P P-B B-Y
0.5 0.5 0.5 0.5 0.5 0.5 0.5 0.5 0.5
AC3
JN.G10
JN.H14 JN.G36
621-01 620-01 629-01 628-01 28 27 000-ac3 616-02 24 2 3 22 21 622-01 625-01 18 021-14 JN.H15
G-R Y-R G-W Lg B G-R Gr W-B Y JN.H16
32 0.5 0.5 0.5 0.5 0.5 0.5 0.5 0.5 0.5 17 CN.761
AMP 025 539-01
1473799-1 G-L
0.85 1 SUMITOMO HM090
- 12 - Socket 538-01
ST
To floor rear console (1/5) 6440-0128
W YAZAKI POSITIVE-LOCK 33194-48790A
2 0.85 7123-8322
Fuse box (A)
4 7
1 063-01 062-01 072-01 016-01 802-01 015-01 014-01 011-01 009-01 013-01 10
V L-B R Br P P Y-R R Y-B Gr
To floor rear console (2/5)

0.5 0.5 0.85 0.85 2.0 0.85 0.85 0.85 0.85 0.85
21 965a-02 23 912-08 25 912-05 27 28 912-06 30
R W W W
3.0 3.0 3.0 5.0
CN.757 F-A
514-01 965a-03 923-01 965a-04 35 36 965b-02 38 965b-03 40
Diode unit (voltage relay) CN.737 JN.G14 JN.G03 Y-R R L-Y R R R
Fuse box (B) 31 0.85 2.0 0.85 2.0 5.0 2.0
2 1 CN.752 4 7 515-01 808-01 021-01 033-01 065-01

P W-R Y O R-L
081-01 075-01 061-01 073-01 068-01
Y-G W B-W P Br
000-vr3 799-03
B W-L DVR
Voltage relay 1 001-01 087-01 082-01 074-01 083-01 084-01 088-01 089-01 091-01 085-01 10 11 0.85 2.0 0.85 0.5 2.0 0.85 2.0 0.5 0.85 0.5 20
G-R W-R G P W-R Gr W-B L-R L L-R 14 17
0.5 0.5 0.5 0.85 1.25 2.0 0.85 1.25 0.85 2.0 1.25 2.0 YAZAKI other
YAZAKI 090 2 1 21 901-01 965c-02 23 361897-0533
7321-9822
YAZAKI 090 000-vr2 704-01 965c-03 25 965c-04 27 965d-02 29 965d-03 30
7123-7729-40 B R-G
VR 0.5 0.85 JN.G01
O
0.5
R
3.0
R
5.0
R
3.0
R
3.0
R
2.0
Fuse box (A) Top view
F-B
JN.G59 JN.G28
799-02 705-01 CN.720 912-07 905-01 965d-04 34 35 36 37 38 39 40
W-L Y-B
OPEN
10A
10A
10A
10A
10A
10A
10A
JN.G02 W Y-G R
Arm angle, T/M learning SW
5A
5A
4 0.5 0.85 3 31 0.85 0.85 3.0
JN.G30 JN.G24 JN.G17 JN.G16 JN.G05
JN.G39 JN.G44 JN.G47 JN.G60
YAZAKI CN 017-01 032-01 812-01 813-01 15 16 17 18 19 20

7123-2446-90 20A
L-W W-L W-B W-L
Blue 3 299-01 298-01
1
11 0.85 0.85 1.25 0.85
P-B G-W 10A
0.5 0.5
DIAG 5 6
YAZAKI other
361897-0533
5A
000-st1
CN.759 B
0.5 4 Fuse box (B) Top view 5A
OPEN
10A
10A
10A
10A
20A
10A
DIAG INC/DEC SW
5A
5A
5A
10A
15A
20A
10A
10A
10A
15A
10A
20A
5A
7123-7464-40 7222-7464-40
2 1
721-02 712-01
W-B W-R
CN.792 20A
YAZAKI
361897-0533
IDC 0.5 0.5 Data link for DIAG (INSITE)

D 15A
769-02 770-01
R R-Y 15A
4 0.5 0.5 3 E S1L-10
W
S1S-98 0.5 C 10A
B S1H-10
10A
OPEN
OPEN
OPEN
OPEN
OPEN
OPEN
OPEN
OPEN
7123-7444-40 7222-7444-40
5A
0.5 L
A 0.5
000-is 711-02
E/G F
B R-W
B
0.85 0.85 YAZAKI
JN.H21 361897-0533
CN.777 G
J CN.773
Diode unit (front wiper SW) H
Relay box (A)
2 1 A5: Lift arm height kickout A4: Bucket leveler A3: High beam A2: Head lamp A1: ECM1
225-01 224-02
DEUTSCH HD DEUTSCH HD 23 21 18 16 13 11 8 6 3 1
DFW L-W Br-W HD10-9-1939P HDC16-9
0.5 0.5 000-r06 17 081-04 000-r03 12 000-r02 7 000-r01 2
208-01 081-06 215-01 421-01 422-01 458-03
000-r07 081-06 000-r04 000-r03 000-r02
YAZAKI 090 YAZAKI 090 R-G B Y-G L-R Y-G B R-Y B Gr O
7123-7729-40 7321-9822 B
0.5 0.5 0.5 0.5 0.5 0.5 0.5 0.5 0.5 0.5 0.5
CN.776 24 000-r04 511-02 512-01 713-01
Diode unit (parking brake) B G-Y Y-B L-W

19 0.5 14 0.85 9 0.85 4 0.85
CN.791
432-01 431-01 073-01 072-01 009-01
3
407-01 408-01 409-03
1
Maintenance Pro Dr. Y-B
DP P G-W R-W
Br-Y W-R P R
0.5 0.5 0.5 25 0.5 20 0.5 15 0.85 10 0.85 5 0.85
3 2 1
YAZAKI 090 YAZAKI 090 581-01 584-01 585-01
7123-9135-50 7321-9834-30 Y-G L-R W-B
Dr. 0.5 0.5 0.5 R-A
6 5 4 48 46 43 41 38 36 33 31 28 26
CN.748 JN.G04
582-01 594-01 583-01
P W-G R-L 47 42 37 000-r08 32 000-r07 27
0.5 0.5 0.5 462-01 011-12 211-01 015-02 000-r09 415-01 426-02 425-02
000-r09 000-r08
2 1 YAZAKI CN V R G-B P B P-W B R-W Y-R
021-04 458-01 7323-2064 B
DE1 Y O Diode unit (ECM1) 0.5 0.5 0.5 0.5 0.5 0.5 0.5 0.5 0.5 0.5
CN.742 0.5 0.5
457-01 527-01 501-01 518-01 517-01
7321-9823-30 P W-B L-R G-W L-W
2 7123-9025-30
457-01 458-02 1 49 0.5 44 0.85 39 0.85 34 0.85 29 0.85
DE2 P O Diode unit (ECM2) 011-06 015-01
0.5 0.5 411-02 075-02 074-02
011-12 015-02
YAZAKI 090 YAZAKI 090 R P Br-Y W P
7123-9025-30 7321-9823-30 0.5
50 0.5 45 0.85 40 0.85 35 0.85 30 0.85
JN.G37 JN.G40
CN.774
A10: Load dump 2 A9: Horn A8: Turn signal (R) A7: Rear working lamp A6: CAB front working lamp
Relay box (B)
YAZAKI
B5: Load dump 1 B4: Brake lamp B3: Engine alternate droop B2: Parking (2) B1: Parking (1) 361897-0553
23 21 18 16 13 11 8 6 3 1 CN.775
461-01
22
011-10 206-01
17
062-04
451-06 12 033-01
409-01
7
406-01 202-01 406-01 021-16
Relay box (C)
451-07 033-02
L R Br-W L-B P-B O R-W Gr G-O Gr Y C4: CAB rear C3: CAB front
0.5 0.5 0.5 0.5 0.5 0.5 0.5 0.5 0.5 0.5 0.5 C5: Secondary steering (opt) working lamp (opt) working lamp (opt) C2: Back lamp C1: ECM2
4 23 21 18 16 13 11 8 6 3 1
471-01 503-01 721-03 000-rb2
R-W W-R W-B B 22 17 000-rc2 12 7 000-rc1 2
455-01 068-02 000-rc3 426-03 425-03 405-01 021-03 458-04
0.5 0.5 000-rc3 000-rc2
24 19 0.5 14 9 0.5 R-W Br B R-W Y-R L-B Y O
B B
011-09 062-03 718-01 021-07 0.5 0.5 0.5 0.5 0.5 0.5 0.5 0.5 0.5 0.5
408-01
011-10 062-04 021-16
Lg-R G-W 525-01 520-01 519-01 505-02 711-01
R L-B Y
25 0.5 20 0.5 15 0.5 10 0.5 5 0.5 L-R G W-B Br-W R-W
24 0.5 19 0.85 14 0.85 9 0.5 4 0.85
R-B
068-01
075-03 074-03 063-01 013-01
CN.739 48 46 43 41 38 36 33 31 28 26 068-02
W P V Gr
Diode unit (Load dump 1) 232-01
47
083-05 231-01 445-01 083-03 225-01
37
082-04 000-rb1 32
416-01 451-07 705-01 033-02 25
Br
0.5 20 0.85 15 0.85 10 0.5 5 0.85
000-rb2
L-Y W-R R-W V W-R L-W G B W-R P-B Y-B O
2 1 0.5 0.5 0.5 0.85 0.5 0.5 0.5 0.5 0.5 0.5 0.85 0.5
471-01 701-04
R-W W-B DBT 532-01 083-02 531-01 29 28 26
0.5 0.5 502-01
083-03 48 47 46 43 42 41 38 37 36 33 32 31
R-B W-R W-L R-L
YAZAKI 090 222-01 305-01 081-09
0.85 0.5 0.85
7123-9025-30 49 44 0.85 39 34 0.85 G-R R-Y Y-G
083-04 082-03 0.5 0.5 0.5
083-05 446-01 082-04 411-03 907-01
W-R R-G G Br-Y L-B 49 44 39 34 29
0.5 0.5
50 0.85 45 0.85 40 0.85 35 0.85 30 0.85
YAZAKI 090
7321-9823-30 B10: Rear washer B9: Rear wiper B8: Front washer B7: Turn signal (L) B6: Neutral relay 50 45 40 35 081-05
081-09
YAZAKI
Y-G
361897-0553
0.5
R-C 30
10 9 8 7 6
JN.G12
C10: (open) C9: (open) C8: (open) C7: (open) C6: Loading lever lock - 13 -
33194-48790A valve (opt)
YAZAKI
361897-0553
ZW310-5A Floor Wiring Diagram
(Rear Console) (4/5)
From To Wire From To
Wire Wire Wire Wire Wire
No. CN/JN CN/JN Dia. Color No. CN/JN CN/JN Dia. Color
CN: Connector, JN: Junction No. Pin No. Pin No. Pin No. Pin
82 021-10 CN.724 Joint connector (B) 10 CN.795 MCZ(E) 4 0.5 Y 163 128-01 CN.793 MCZ(D) 28 CN.702 Control lever pilot primary pressure 2 0.5 Y
From To Wire sensor
Wire Wire 83 021-13 CN.756 A/C operation panel (A) 1 JN.G18 0.5 Y
CN/JN CN/JN Color 164 129-01 CN.794 A/C gas pressure sensor 2 CN.793 MCZ(D) 18 0.5 P
No. Pin Pin Dia.
No. No. 84 021-14 JN.G18 CN.751 Air conditioner 3 17 0.5 Y 165 131-01 CN.706 Rear chassis CN.202 5 CN.799 MCZ(C) 14 0.5 R-L
1 000-ac1 JN.G52 CN.785 GND(A) 1 2.0 B
85 021-15 JN.G18 CN.743 Air conditioner 1 3 0.5 Y 166 134-01 CN.728 Throttle pedal 1 CN.793 MCZ(D) 14 0.5 P-B
2 000-ac2 CN.743 Air conditioner 1 2 JN.G52 2.0 B
86 021-16 CN.774 Relay box (B) 5 CN.774 Relay box (B) 1 0.5 Y 167 135-01 CN.793 MCZ(D) 8 CN.706 Rear chassis CN.202 7 0.5 Y
3 000-ac3 JN.G52 CN.751 Air conditioner 3 26 0.5 B
87 032-01 CN.737 Fuse box (B) 12 CN.710 Front console CN.401 9 0.85 W-L 168 136-01 CN.705 Rear chassis CN.201 36 CN.793 MCZ(D) 19 0.5 L-W
4 000-acp CN.789 A/C gas Hi/Lo pressure SW 2 CN.785 GND(A) 1 0.5 B
88 033-01 CN.774 Relay box (B) 11 CN.733 Fuse box (A) 14 0.5 O 169 137-01 CN.797 MCZ(F) 9 CN.705 Rear chassis CN.201 12 0.5 Br-Y
5 000-ap CN.753 A/C operation panel (B) 9 CN.785 GND(A) 1 0.5 B
89 033-02 CN.774 Relay box (B) 26 CN.774 Relay box (B) 11 0.5 O 170 138-01 CN.701 Service brake secondary pressure 2 CN.793 MCZ(D) 17 0.5 G-Y
6 000-bls CN.787 GND(C) 1 CN.767 Brake lamp SW 3 0.5 B sensor (CC)
90 061-01 CN.733 Fuse box (A) 18 CN.705 Rear chassis CN.201 43 0.5 B-W 171 139-01 CN.793 MCZ(D) 9 CN.706 Rear chassis CN.202 8 0.5 Gr
7 000-bm CN.778 GND(D) 1 CN.729 Rear view monitor 2 0.5 B
91 062-01 CN.733 Fuse box (A) 2 JN.G30 0.5 L-B 172 141-01 CN.705 Rear chassis CN.201 31 CN.799 MCZ(C) 7 0.5 Br
8 000-bt CN.763 Option GND (Bt) 1 CN.786 GND(B) 1 2.0 B
92 062-02 JN.G30 CN.767 Brake lamp SW 1 0.5 L-B 173 142-01 CN.799 MCZ(C) 1 CN.706 Rear chassis CN.202 11 0.5 W-L
9 000-cab CN.768 CAB-B 4 CN.787 GND(C) 1 3.0 B
93 062-03 JN.G30 CN.774 Relay box (B) 20 0.5 L-B 174 143-01 CN.799 MCZ(C) 8 CN.726 Themistor assy (outside temp. MC) 1 0.5 L-R
10 000-cs1 JN.G61 CN.778 GND(D) 1 0.5 B
94 062-04 CN.774 Relay box (B) 16 CN.774 Relay box (B) 20 0.5 L-B
11 000-cs2 CN.780 Column shift lever (T/M) 1 JN.G61 0.5 B 175 151-01 CN.705 Rear chassis CN.201 2 CN.713 Front console CN.404 10 0.5 R-L
95 062-05 CN.781 Column shift lever (turn) 2 JN.G30 0.5 L-B 153-01 CN.711 Front console CN.402 17 CN.705 Rear chassis CN.201 45 0.5 Y-B
12 000-cs3 JN.G61 CN.780 Column shift lever (T/M) 6 0.5 B 176
96 063-01 CN.733 Fuse box (A) 1 CN.775 Relay box (C) 10 0.5 V 154-01 CN.711 Front console CN.402 18 CN.705 Rear chassis CN.201 46 0.5 Gr
13 000-dc CN.730 DC/DC converter 1 CN.785 GND(A) 1 0.85 B 177
14 000-fc CN.710 10 CN.778 GND(D) 2.0 B 97 065-01 CN.733 Fuse box (A) 15 JN.G07 2.0 R-L 182-01 CN.703 Transmission CN.101 2 CN.795 MCZ(E) 7 0.5 W-B
Front console CN.401 1 178
15 000-fls CN.754 Flasher unit 2 CN.787 GND(C) 0.85 B 98 065-02 JN.G07 CN.797 MCZ(F) 1 0.85 R-L 179 184-01 CN.703 Transmission CN.101 8 CN.795 MCZ(E) 8 0.5 G-B
1
16 000-gps CN.750 8 CN.785 GND(A) 0.5 B 99 065-03 CN.797 MCZ(F) 2 JN.G07 0.85 R-L
GPS or GSM 1 180 186-01 CN.703 Transmission CN.101 4 CN.795 MCZ(E) 9 0.5 Y-B
17 000-is CN.792 Data link for DIAG (INSITE) 1 CN.786 GND(B) 1 0.85 B 100 065-04 JN.G07 CN.797 MCZ(F) 3 0.85 R-L 181 188-01 CN.703 Transmission CN.101 6 CN.795 MCZ(E) 10 0.5 L-B
18 000-mc1 JN.G54 CN.778 GND(D) 1 2.0 B 101 068-01 CN.733 Fuse box (A) 20 CN.775 Relay box (C) 25 0.5 Br 182 202-01 CN.774 Relay box (B) 3 CN.710 Front console CN.401 12 0.5 G-O
19 000-mc2 CN.797 MCZ(F) 4 JN.G54 0.85 B 102 068-02 CN.775 Relay box (C) 21 CN.775 Relay box (C) 25 0.5 Br 183 206-01 CN.774 Relay box (B) 18 CN.767 Brake lamp SW 2 0.5 Br-W
20 000-mc3 CN.797 MCZ(F) 5 JN.G54 0.85 B 103 072-01 CN.733 Fuse box (A) 3 CN.773 Relay box (A) 10 0.85 R 184 208-01 CN.773 Relay box (A) 23 CN.705 Rear chassis CN.201 52 0.5 R-G
21 000-mc4 JN.G54 CN.797 MCZ(F) 6 0.85 B 104 073-01 CN.733 Fuse box (A) 19 CN.773 Relay box (A) 15 0.85 P 185 211-01 CN.773 Relay box (A) 43 JN.G26 0.5 G-B
22 000-mc5 JN.G54 CN.795 MCZ(E) 1 0.85 B 105 074-01 CN.737 Fuse box (B) 4 JN.G40 2.0 P 211-02 JN.G26 CN.731 Wiper, horn SW 4 0.5 G-B
186
23 000-mc6 CN.795 MCZ(E) 2 JN.G54 0.85 B 106 074-02 JN.G40 CN.773 Relay box (A) 30 0.85 P 187 211-03 JN.G26 CN.713 Front console CN.404 5 0.5 G-B
24 000-op1 CN.740 Option GND (ACC1) 1 CN.785 GND(A) 1 2.0 B 107 074-03 JN.G40 CN.775 Relay box (C) 15 0.85 P 188 211-04 JN.G26 CN.717 Side console 2 CN.601 6 0.5 G-B
25 000-op2 CN.741 Option GND (ACC2) 1 CN.786 GND(B) 1 1.25 B 108 075-01 CN.733 Fuse box (A) 17 JN.G37 2.0 W 189 215-01 CN.705 Rear chassis CN.201 26 CN.773 Relay box (A) 18 0.5 L-R
26 000-op3 CN.762 Option GND (ACC3) 1 CN.786 GND(B) 1 0.85 B 109 075-02 CN.773 Relay box (A) 35 JN.G37 0.85 W 190 222-01 CN.727 Side console 4 4 CN.775 Relay box (C) 28 0.5 G-R
27 000-r01 CN.786 GND(B) 1 CN.773 Relay box (A) 3 0.5 B 110 075-03 JN.G37 CN.775 Relay box (C) 20 0.85 W 191 224-01 JN.G23 CN.711 Front console CN.402 10 0.5 Br-W
28 000-r02 CN.773 Relay box (A) 8 CN.773 Relay box (A) 3 0.5 B
111 081-01 CN.733 Fuse box (A) 16 CN.724 Joint connector (B) 16 0.85 Y-G 192 224-02 CN.777 Diode unit (F wiper SW) 1 JN.G23 0.5 Br-W
112 081-02 CN.717 Side console 2 CN.601 4 CN.724 Joint connector (B) 17 0.5 Y-G 193 224-03 JN.G23 CN.731 Wiper, horn SW 8 0.5 Br-W
113 081-03 CN.724 Joint connector (B) 18 CN.715 Side console 1 CN.501 11 0.5 Y-G 194 225-01 CN.777 Diode unit (F wiper SW) 2 CN.774 Relay box (B) 38 0.5 L-W
31 000-r06 CN.786 GND(B) 1 CN.773 Relay box (A) 22 0.5 B
114 081-04 CN.724 Joint connector (B) 19 CN.773 Relay box (A) 16 0.5 Y-G 195 227-01 CN.731 Wiper, horn SW 3 CN.713 Front console CN.404 13 0.5 B-Y
115 081-05 CN.724 Joint connector (B) 20 CN.775 Relay box (C) 30 0.5 Y-G 196 228-01 CN.711 Front console CN.402 7 CN.731 Wiper, horn SW 1 0.5 P-B
116 081-06 CN.773 Relay box (A) 21 CN.773 Relay box (A) 16 0.5 Y-G 197 229-01 CN.711 Front console CN.402 8 CN.731 Wiper, horn SW 2 0.5 Br-Y
117 081-09 CN.775 Relay box (C) 30 CN.775 Relay box (C) 26 0.5 Y-G 198 231-01 CN.774 Relay box (B) 43 CN.731 Wiper, horn SW 6 0.5 R-W
35 000-rb1 CN.774 Relay box (B) 33 CN.786 GND(B) 1 0.5 B
118 082-01 CN.737 Fuse box (B) 3 JN.G24 1.25 G 199 232-01 CN.774 Relay box (B) 48 CN.731 Wiper, horn SW 5 0.5 L-Y
36 000-rb2 CN.774 Relay box (B) 9 CN.774 Relay box (B) 33 0.5 B
119 082-02 JN.G24 CN.712 Front console CN.403 16 1.25 G 235-01 CN.795 CN.717 Side console 2 CN.601 8 0.5 G-R
37 000-rc1 CN.786 GND(B) 1 CN.775 Relay box (C) 3 0.5 B 200 MCZ(E) 22
120 082-03 JN.G24 CN.774 Relay box (B) 40 0.85 G 236-01 CN.795 CN.717 Side console 2 CN.601 12 0.5 P-W
38 000-rc2 CN.775 Relay box (C) 3 CN.775 Relay box (C) 13 0.5 B 201 MCZ(E) 23
121 082-04 CN.774 Relay box (B) 40 CN.774 Relay box (B) 36 0.5 G 202 241-01 CN.780 Column shift lever (T/M) 4 CN.769 Diode unit (Column F) 2 0.5 W-R
39 000-rc3 CN.775 Relay box (C) 18 CN.775 Relay box (C) 13 0.5 B
122 083-01 JN.G39 CN.737 Fuse box (B) 5 0.85 W-R 203 242-01 CN.780 Column shift lever (T/M) 3 CN.779 Diode unit (Column N) 1 0.5 L-Y
40 000-sc1 CN.715 Side console 1 CN.501 1 CN.778 GND(D) 1 0.85 B
1
123 083-02 JN.G39 CN.774 Relay box (B) 44 0.85 W-R 204 243-01 CN.780 Column shift lever (T/M) 2 CN.770 Diode unit (Column R) 2 0.5 G-W
41 000-sc2 JN.G62 CN.778 GND(D) 0.5 B
42 000-sc3 CN.717 Side console 2 CN.601 7 JN.G62 0.5 B
124 083-03 CN.774 Relay box (B) 41 CN.774 Relay box (B) 44 0.5 W-R 205 244-01 CN.771 Diode unit (opt-F) 2 CN.717 Side console 2 CN.601 10 0.5 W-L
43 000-sc4 CN.787 GND(C) 1 CN.727 Side console 4 2 0.5 B 125 083-04 JN.G39 CN.774 Relay box (B) 50 0.85 W-R 206 246-01 CN.772 Diode unit (opt-R) 2 CN.717 Side console 2 CN.601 13 0.5 Y-B
126 083-05 CN.774 Relay box (B) 50 CN.774 Relay box (B) 46 0.5 W-R 207 247-01 CN.795 MCZ(E) 16 CN.780 Column shift lever (T/M) 8 0.5 L-Y
44 000-sc5 CN.717 Side console 2 CN.601 1 JN.G62 0.5 B
45 000-sh CN.790 Air suspension seat power (opt) 2 CN.785 GND(A) 1 2.0 B 127 083-06 CN.734 CAB-A 3 JN.G39 0.85 W-R 208 248-01 CN.795 MCZ(E) 21 CN.780 Column shift lever (T/M) 7 0.5 Br-Y
128 084-01 CN.743 Air conditioner 1 4 CN.737 Fuse box (B) 6 1.25 Gr
46 000-st1 CN.720 Arm angle, T/M learning SW 4 CN.787 GND(C) 1 0.5 B 209 249-01 CN.793 MCZ(D) 11 CN.715 Side console 1 CN.501 7 0.5 Br
47 000-sw CN.713 CN.778 1.25 B 129 085-01 CN.743 Air conditioner 1 1 CN.737 Fuse box (B) 10 2.0 L-R Side console 1 CN.501
Front console CN.404 2 GND(D) 1 210 251-01 CN.797 MCZ(F) 10 CN.715 17 0.5 Gr
48 000-vr JN.G59 CN.787 GND(C) 1 0.85 B 130 087-01 CN.737 Fuse box (B) 2 CN.713 Front console CN.404 1 0.85 W-R 211 252-01 CN.797 MCZ(F) 7 CN.715 Side console 1 CN.501 6 0.5 W-L
49 000-vr2 CN.752 Voltage relay 2 JN.G59 0.5 B 131 088-01 CN.737 Fuse box (B) 7 CN.730 DC/DC converter 2 0.85 W-B 212 253-01 CN.793 MCZ(D) 23 CN.715 Side console 1 CN.501 20 0.5 L-B
50 000-vr3 JN.G59 CN.757 Diode unit (voltage relay) 2 0.5 B 132 089-01 CN.790 Air suspension seat power (opt) 1 CN.737 Fuse box (B) 8 2.0 L-R 213 254-01 CN.797 MCZ(F) 23 CN.713 Front console CN.404 20 0.5 Br-W
51 000-wip CN.731 Wiper, horn SW 7 CN.787 GND(C) 1 0.5 B 133 091-01 CN.768 CAB-B 3 CN.737 Fuse box (B) 9 1.25 L 214 255-01 CN.797 MCZ(F) 22 CN.713 Front console CN.404 19 0.5 V
52 001-01 CN.734 CAB-A 5 CN.737 Fuse box (B) 1 0.5 G-R 134 101-01 CN.703 Transmission CN.101 1 CN.795 MCZ(E) 17 0.5 Y-L 215 257-01 CN.797 MCZ(F) 21 CN.715 Side console 1 CN.501 15 0.5 L-Y
53 009-01 CN.733 Fuse box (A) 9 CN.773 Relay box (A) 5 0.85 Y-B 135 102-01 CN.703 Transmission CN.101 3 CN.795 MCZ(E) 19 0.5 L-W 216 258-01 CN.797 MCZ(F) 11 CN.717 Side console 2 CN.601 15 0.5 R-Y
54 011-01 CN.733 Fuse box (A) 8 JN.G05 0.85 R 136 103-01 CN.703 Transmission CN.101 5 CN.795 MCZ(E) 20 0.5 W-R 217 259-01 CN.797 MCZ(F) 8 CN.715 Side console 1 CN.501 8 0.5 P-W
55 011-02 CN.721 Joint connector (A) 2 JN.G06 0.85 R 137 105-01 CN.703 Transmission CN.101 7 CN.795 MCZ(E) 18 0.5 L-Y 218 261-01 CN.769 Diode unit (Column F) 1 CN.795 MCZ(E) 14 0.5 R-L
56 011-03 CN.721 Joint connector (A) 3 CN.750 GPS or GSM 1 0.5 R 138 113-01 CN.799 MCZ(C) 2 CN.704 Transmission CN.102 4 0.5 B-W 219 262-01 CN.779 Diode unit (Column N) 2 CN.795 MCZ(E) 13 0.5 Y-G
57 011-04 CN.721 Joint connector (A) 4 CN.712 Front console CN.403 14 0.85 R 139 121-01 JN.G48 CN.702 Control lever pilot primary pressure 3 0.5 P 220 263-01 CN.770 Diode unit (Column R) 1 CN.795 MCZ(E) 15 0.5 W-L
sensor
58 011-05 JN.G05 CN.721 Joint connector (A) 1 0.85 R 140 121-02 CN.721 Joint connector (A) 6 CN.728 Throttle pedal 3 0.5 P 221 267-01 CN.795 MCZ(E) 3 CN.713 Front console CN.404 17 0.5 W-G
59 011-06 JN.G05 CN.773 Relay box (A) 50 0.5 R 141 121-03 CN.721 7 CN.704 0.5
Joint connector (A) Transmission CN.102 3 P 222 268-01 CN.795 MCZ(E) 11 CN.713 Front console CN.404 18 0.5 G-Y
60 011-07 JN.G06 CN.795 MCZ(E) 5 0.85 R
142 121-04 CN.706 4 CN.721 0.5
Rear chassis CN.202 Joint connector (A) 8 P 223 270-01 CN.793 MCZ(D) 24 CN.713 Front console CN.404 14 0.5 G-R
61 011-08 JN.G06 CN.795 MCZ(E) 6 0.85 R
143 121-05 CN.721 5 JN.G48 0.5
Joint connector (A) P 224 278-01 CN.771 Diode unit (opt-F) 1 CN.793 MCZ(D) 12 0.5 O
62 011-09 JN.G05 CN.774 Relay box (B) 25 0.5 R
144 121-06 JN.G48 CN.797 MCZ(F) 25 0.5 P 225 279-01 CN.772 Diode unit (opt-R) 1 CN.793 MCZ(D) 13 0.5 Br-W
63 011-10 CN.774 Relay box (B) 25 CN.774 Relay box (B) 21 0.5 R
145 122-01 JN.G49 CN.797 MCZ(F) 16 0.5 V 226 293-01 CN.797 MCZ(F) 13 CN.715 Side console 1 CN.501 2 0.5 Gr-L
64 011-12 CN.773 Relay box (A) 50 CN.773 Relay box (A) 46 0.5 R
146 122-02 CN.706 Rear chassis CN.202 3 CN.721 Joint connector (A) 16 0.5 V 227 294-01 CN.797 MCZ(F) 14 CN.715 Side console 1 CN.501 3 0.5 W-G
65 013-01 CN.733 Fuse box (A) 10 CN.775 Relay box (C) 5 0.85 Gr
147 122-03 CN.721 Joint connector (A) 17 CN.704 Transmission CN.102 1 0.5 V 228 295-01 CN.797 MCZ(F) 18 CN.715 Side console 1 CN.501 4 0.5 L-B
66 014-01 CN.733 Fuse box (A) 7 JN.G46 0.85 Y-R
148 122-04 CN.721 Joint connector (A) 18 CN.728 Throttle pedal 2 0.5 V 229 296-01 CN.797 MCZ(F) 19 CN.715 Side console 1 CN.501 5 0.5 W-Y
67 014-02 JN.G46 CN.710 Front console CN.401 7 0.5 Y-R
149 122-05 CN.721 Joint connector (A) 15 JN.G49 0.5 V 230 298-01 CN.795 MCZ(E) 24 CN.720 Arm angle, T/M learning SW 1 0.5 G-W
68 014-03 JN.G46 CN.754 Flasher unit 4 0.85 Y-R
150 122-06 JN.G49 CN.702 Control lever pilot primary pressure 1 0.5 V
69 015-01 CN.733 Fuse box (A) 6 CN.773 Relay box (A) 45 0.85 P sensor
231 299-01 CN.795 MCZ(E) 12 CN.720 Arm angle, T/M learning SW 2 0.5 P-B
151 123-01 CN.797 MCZ(F) 26 JN.G08 0.5 W 232 305-01 CN.727 Side console 4 1 CN.775 Relay box (C) 27 0.5 R-Y
70 015-02 CN.773 Relay box (A) 41 CN.773 Relay box (A) 45 0.5 P
152 123-02 JN.G08 CN.701 Service brake secondary pressure 3 0.5 W 233 321-01 CN.798 MCZ(A) 16 CN.705 Rear chassis CN.201 41 0.5 R-Y
71 016-01 CN.782 Column shift lever (lighting) 6 CN.733 Fuse box (A) 4 0.85 Br sensor (CC)
153 123-03 CN.706 Rear chassis CN.202 6 JN.G08 0.5 W 234 322-01 CN.798 MCZ(A) 17 CN.705 Rear chassis CN.201 42 0.5 L-Y
72 017-01 CN.734 CAB-A 1 CN.737 Fuse box (B) 11 0.85 L-W
154 123-04 JN.G08 CN.794 A/C gas pressure sensor 1 0.5 W 235 325-01 CN.755 MCZ(B) 16 CN.705 Rear chassis CN.201 10 0.5 W-B
73 021-01 CN.733 Fuse box (A) 13 CN.724 Joint connector (B) 1 0.85 Y
2 155 124-01 CN.797 MCZ(F) 17 JN.G09 0.5 G-B 236 326-01 CN.755 MCZ(B) 15 CN.705 Rear chassis CN.201 11 0.5 B-R
74 021-02 CN.724 Joint connector (B) CN.712 Front console CN.403 15 0.85 Y
3 156 124-02 JN.G09 CN.701 Service brake secondary pressure 1 0.5 G-B 237 327-01 CN.798 MCZ(A) 19 CN.706 Rear chassis CN.202 12 0.5 Y-R
75 021-03 CN.724 Joint connector (B) CN.775 Relay box (C) 6 0.5 Y
sensor (CC)
4 Diode unit (ECM1) 2 157 124-03 JN.G09 CN.705 Rear chassis CN.201 29 0.5 G-B 238 328-01 CN.798 MCZ(A) 18 CN.706 Rear chassis CN.202 13 0.5 G-Y
76 021-04 CN.724 Joint connector (B) CN.748 0.5 Y
77 021-05 CN.724 Joint connector (B) 5 JN.G18 0.5 Y 158 124-04 JN.G09 CN.794 A/C gas pressure sensor 3 0.5 G-B 239 331-01 CN.798 MCZ(A) 25 CN.706 Rear chassis CN.202 14 0.5 Y-B
- 14 - 78 021-06 CN.724 Joint connector (B) 6 CN.723 Diode unit (key ON power) 2 0.5 Y 159 124-05 JN.G09 CN.726 Themistor assy (outside temp. MC) 2 0.5 G-B 240 332-01 CN.798 MCZ(A) 24 CN.706 Rear chassis CN.202 15 0.5 W-B
79 021-07 CN.724 Joint connector (B) 7 CN.774 Relay box (B) 5 0.5 Y 160 125-01 CN.799 MCZ(C) 13 CN.704 Transmission CN.102 2 0.5 G 241 341-01 CN.706 Rear chassis CN.202 1 CN.715 Side console 1 CN.501 13 0.5 L-R
80 021-08 CN.724 Joint connector (B) 8 CN.705 Rear chassis CN.201 15 0.5 Y 161 126-01 CN.793 MCZ(D) 16 CN.706 Rear chassis CN.202 10 0.5 Y-B 242 342-01 CN.706 Rear chassis CN.202 2 CN.715 Side console 1 CN.501 12 0.5 G-B
81 021-09 CN.724 Joint connector (B) 9 CN.750 GPS or GSM 2 0.5 Y 162 127-01 CN.793 MCZ(D) 15 CN.706 Rear chassis CN.202 9 0.5 R-L 243 351-01 CN.703 Transmission CN.101 18 CN.798 MCZ(A) 12 0.5 W
ZW310-5A Floor Wiring Diagram CN: Connector, JN: Junction CN: Connector, JN: Junction
(Rear Console) (5/5) Wire

No. CN/JN
From
CN/JN
To
Wire
Dia.
Wire
Color
Wire
No. CN/JN
From
CN/JN
To
Wire
Dia.
Wire
Color
No. Pin No. Pin No. Pin No. Pin
From To
325 515-05 CN.724 Joint connector (B) 15 CN.727 Side console 4 3 0.5 P 406 716-01 CN.705 Rear chassis CN.201 20 CN.788 Emergency throttle 1 0.5 W
Wire Wire Wire
CN/JN CN/JN 326 517-01 JN.G38 CN.773 Relay box (A) 29 0.85 L-W 407 717-01 CN.705 Rear chassis CN.201 21 CN.788 Emergency throttle 2 0.5 B
No. Color
No. Pin No. Pin Dia. 327 517-02 CN.768 CAB-B 1 JN.G38 0.85 L-W 408 718-01 CN.705 Rear chassis CN.201 27 CN.774 Relay box (B) 15 0.5 Lg-R
244 352-01 CN.703 Transmission CN.101 17 CN.798 MCZ(A) 13 0.5 B-W
328 517-03 JN.G38 CN.711 Front console CN.402 11 0.5 L-W 409 721-01 CN.705 Rear chassis CN.201 30 JN.G34 0.5 W-B
245 353-01 CN.703 Transmission CN.101 20 CN.798 MCZ(A) 15 0.5 L
329 518-01 CN.773 Relay box (A) 34 CN.705 Rear chassis CN.201 9 0.85 G-W 410 721-02 JN.G34 CN.759 DIAG INC/DEC SW 2 0.5 W-B
246 354-01 CN.703 Transmission CN.101 19 CN.798 MCZ(A) 14 0.5 G-B
330 519-01 CN.766 CAB-F 1 CN.775 Relay box (C) 14 0.85 W-B 411 721-03 CN.774 Relay box (B) 14 JN.G34 0.5 W-B
247 355-01 CN.703 Transmission CN.101 10 CN.798 MCZ(A) 3 0.5 L-W
331 520-01 CN.732 CAB-R 1 CN.775 Relay box (C) 19 0.85 G 412 724-01 CN.765 MAINTENANCE (E/G fault lamp) 2 CN.705 Rear chassis CN.201 35 0.5 Y-B
248 356-01 CN.703 Transmission CN.101 9 CN.798 MCZ(A) 2 0.5 G-W
332 525-01 CN.706 Rear chassis CN.202 16 CN.775 Relay box (C) 24 0.5 L-R 413 769-02 CN.705 Rear chassis CN.201 24 CN.759 DIAG INC/DEC SW 4 0.5 R
249 357-01 CN.703 Transmission CN.101 12 CN.798 MCZ(A) 8 0.5 R-L
333 527-01 CN.773 Relay box (A) 44 CN.705 Rear chassis CN.201 51 0.85 W-B 414 770-01 CN.705 Rear chassis CN.201 23 CN.759 DIAG INC/DEC SW 3 0.5 R-Y
250 358-01 CN.703 Transmission CN.101 11 CN.798 MCZ(A) 9 0.5 B-Y
334 531-01 CN.705 Rear chassis CN.201 39 CN.774 Relay box (B) 39 0.85 W-L 415 799-01 JN.G28 CN.705 Rear chassis CN.201 50 0.5 W-L
251 359-01 CN.703 Transmission CN.101 14 CN.798 MCZ(A) 11 0.5 R-W
335 532-01 CN.774 Relay box (B) 49 CN.705 Rear chassis CN.201 40 0.85 R-B 416 799-02 CN.752 Voltage relay 4 JN.G28 0.5 W-L
252 360-01 CN.703 Transmission CN.101 13 CN.798 MCZ(A) 10 0.5 B-L
336 535-01 CN.799 MCZ(C) 3 CN.717 Side console 2 CN.601 9 0.5 Br-Y 417 799-03 JN.G28 CN.757 Diode unit (voltage relay) 1 0.5 W-L
253 361-01 CN.703 Transmission CN.101 16 CN.798 MCZ(A) 4 0.5 R
254 362-01 CN.703 Transmission CN.101 15 CN.798 MCZ(A) 5 0.5 B-R 337 536-01 CN.799 MCZ(C) 4 CN.717 Side console 2 CN.601 11 0.5 L-Y 418 802-01 CN.736 Opt power supply (Bt) 1 CN.733 Fuse box (A) 5 2.0 P
255 405-01 CN.775 Relay box (C) 8 CN.799 MCZ(C) 17 0.5 L-B 338 538-01 CN.730 DC/DC converter 4 CN.761 Socket 2 0.85 W 419 808-01 JN.G53 CN.733 Fuse box (A) 12 2.0 W-R
256 406-01 CN.774 Relay box (B) 2 CN.774 Relay box (B) 6 0.5 Gr 339 539-01 CN.730 DC/DC converter 3 CN.761 Socket 1 0.85 G-L 420 808-02 CN.735 Opt power supply (ACC1) 1 JN.G53 2.0 W-R
257 407-01 CN.776 Diode unit (parking brake) 3 CN.705 Rear chassis CN.201 44 0.5 P 340 542-01 CN.755 MCZ(B) 17 CN.711 Front console CN.402 4 0.5 V 421 808-03 JN.G53 CN.729 Rear view monitor 1 0.5 W-R
258 408-01 CN.776 Diode unit (parking brake) 2 CN.774 Relay box (B) 10 0.5 G-W 341 552-01 CN.799 MCZ(C) 9 CN.713 Front console CN.404 12 0.5 R-B 422 812-01 CN.738 Opt power supply (ACC2) 1 CN.737 Fuse box (B) 13 1.25 W-B
259 409-01 JN.G44 CN.774 Relay box (B) 8 0.5 R-W 342 553-01 CN.799 MCZ(C) 6 CN.711 Front console CN.402 9 0.5 O 423 813-01 CN.803 Opt power supply (ACC3) 1 CN.737 Fuse box (B) 14 0.85 W-L
260 409-02 JN.G44 CN.710 Front console CN.401 15 0.5 R-W 343 554-01 JN.G35 CN.705 Rear chassis CN.201 34 0.5 Br 424 840-01 CN.705 Rear chassis CN.201 32 CN.804 For option SW (not used) 1 0.5 Y-G
261 409-03 JN.G44 CN.776 Diode unit (parking brake) 1 0.5 R-W 344 554-02 CN.711 Front console CN.402 3 JN.G35 0.5 Br 425 901-01 CN.737 Fuse box (B) 21 CN.710 Front console CN.401 2 0.5 O
262 411-01 CN.754 Flasher unit 3 JN.G47 0.85 Br-Y 345 554-03 JN.G35 CN.765 MAINTENANCE (E/G fault lamp) 1 0.5 Br 426 905-01 CN.737 Fuse box (B) 32 CN.710 Front console CN.401 4 0.85 Y-G
263 411-02 JN.G47 CN.773 Relay box (A) 40 0.85 Br-Y 346 555-01 CN.799 MCZ(C) 10 CN.713 Front console CN.404 7 0.5 W-R 427 907-01 CN.774 Relay box (B) 30 CN.710 Front console CN.401 8 0.85 L-B
264 411-03 JN.G47 CN.774 Relay box (B) 35 0.85 Br-Y 347 556-01 CN.711 Front console CN.402 2 CN.705 Rear chassis CN.201 33 0.5 W-R 428 912-02 JN.G29 CN.710 Front console CN.401 1 1.25 W
265 412-01 JN.G22 CN.710 Front console CN.401 14 0.5 L 348 577-01 CN.712 Front console CN.403 13 CN.750 GPS or GSM 4 0.5 Y-R 429 912-03 JN.G29 JN.G04 8.0 W
266 412-02 JN.G22 CN.783 Diode unit (Flasher1) 1 0.5 L 349 578-01 CN.712 Front console CN.403 4 CN.750 GPS or GSM 6 0.5 Br 430 912-04 JN.G29 CN.747 Rear chassis (70A fusible link) 1 8.0 W
267 412-03 CN.784 Diode unit (Flasher2) 3 JN.G22 0.5 L 350 579-01 CN.712 Front console CN.403 5 CN.750 GPS or GSM 7 0.5 Gr 431 912-05 CN.733 Fuse box (A) 26 JN.G04 3.0 W
268 413-01 CN.781 Column shift lever (turn) 1 CN.783 Diode unit (Flasher1) 3 0.5 R-W 351 581-01 CN.791 Maintenance Pro Dr. 3 CN.712 Front console CN.403 3 0.5 Y-G 432 912-06 JN.G04 CN.733 Fuse box (A) 29 5.0 W
269 414-01 CN.781 Column shift lever (turn) 4 CN.784 Diode unit (Flasher2) 1 0.5 L-Y
352 582-01 CN.791 Maintenance Pro Dr. 6 CN.712 Front console CN.403 1 0.5 P 433 912-07 CN.737 Fuse box (B) 31 JN.G04 0.85 W
270 415-01 CN.783 Diode unit (Flasher1) 2 CN.773 Relay box (A) 36 0.5 P-W
353 583-01 CN.791 Maintenance Pro Dr. 4 CN.712 Front console CN.403 7 0.5 R-L 434 912-08 CN.733 Fuse box (A) 24 JN.G04 3.0 W
271 416-01 CN.784 Diode unit (Flasher2) 2 CN.774 Relay box (B) 31 0.5 W-R
2
354 584-01 CN.791 Maintenance Pro Dr. 2 CN.712 Front console CN.403 0.5 L-R 435 923-01 CN.733 Fuse box (A) 33 CN.710 Front console CN.401 3 0.85 L-Y
272 421-01 CN.782 Column shift lever (lighting) 2 CN.773 Relay box (A) 11 0.5 R-Y
11
355 585-01 CN.791 Maintenance Pro Dr. 1 CN.712 Front console CN.403 0.5 W-B 436 965a-01 CN.709 Rear chassis CN.205 1 JN.G14 8.0 R
273 422-01 CN.782 Column shift lever (lighting) 3 CN.773 Relay box (A) 6 0.5 Gr
356 591-01 CN.705 Rear chassis CN.201 37 CN.713 Front console CN.404 8 0.5 G-Y 437 965a-02 CN.733 Fuse box (A) 22 JN.G14 3.0 R
274 425-01 JN.G16 CN.710 Front console CN.401 6 0.5 Y-R
357 592-01 CN.705 Rear chassis CN.201 38 CN.713 Front console CN.404 9 0.5 V 438 965a-03 CN.733 Fuse box (A) 32 JN.G14 2.0 R
275 425-02 CN.773 Relay box (A) 26 JN.G16 0.5 Y-R
358 593-01 CN.712 Front console CN.403 6 CN.750 GPS or GSM 5 0.5 B-Y 439 965a-04 CN.733 Fuse box (A) 34 JN.G14 2.0 R
276 425-03 JN.G16 CN.775 Relay box (C) 11 0.5 Y-R
359 594-01 CN.791 Maintenance Pro Dr. 5 CN.712 Front console CN.403 8 0.5 W-G 440 965b-01 CN.709 Rear chassis CN.205 2 JN.G03 8.0 R
277 426-01 JN.G17 CN.710 Front console CN.401 5 0.5 R-W
360 595-01 CN.799 MCZ(C) 5 CN.713 Front console CN.404 16 0.5 G-R 441 965b-02 CN.733 Fuse box (A) 37 JN.G03 5.0 R
278 426-02 CN.773 Relay box (A) 31 JN.G17 0.5 R-W
361 596-01 CN.712 Front console CN.403 12 CN.750 GPS or GSM 14 0.5 Gr 442 965b-03 CN.733 Fuse box (A) 39 JN.G03 2.0 R
279 426-03 JN.G17 CN.775 Relay box (C) 16 0.5 R-W
362 597-01 CN.712 Front console CN.403 10 CN.750 GPS or GSM 16 0.5 Y-R 443 965c-01 CN.708 Rear chassis CN.204 1 JN.G01 8.0 R
280 431-01 CN.773 Relay box (A) 20 CN.717 Side console 2 CN.601 16 0.5 W-R
363 598-01 CN.712 Front console CN.403 9 CN.750 GPS or GSM 15 0.5 R-W 444 965c-02 JN.G01 CN.737 Fuse box (B) 22 3.0 R
281 432-01 CN.717 Side console 2 CN.601 2 CN.773 Relay box (A) 25 0.5 Br-Y
282 445-01 CN.734 CN.774 Relay box (B) 42 0.85 V
364 601-01 CN.705 Rear chassis CN.201 47 CN.744 Air conditioner 2 9 1.25 G 445 965c-03 JN.G01 CN.737 Fuse box (B) 24 5.0 R
CAB-A 4
283 446-01 CN.734 CAB-A 2 CN.774 Relay box (B) 45 0.85 R-G 365 605-01 CN.756 A/C operation panel (A) 2 CN.789 A/C gas Hi/Lo pressure SW 1 0.5 L-W 446 965c-04 CN.737 Fuse box (B) 26 JN.G01 3.0 R
284 451-01 CN.769 Diode unit (Column F) 3 JN.G10 0.5 P-B 366 611-01 CN.756 A/C operation panel (A) 3 CN.713 Front console CN.404 3 0.5 W-G 447 965d-01 CN.708 Rear chassis CN.204 2 JN.G02 8.0 R
285 451-02 JN.G10 CN.770 Diode unit (column R) 3 0.5 P-B 367 612-01 CN.756 A/C operation panel (A) 4 JN.G20 0.5 P 448 965d-02 JN.G02 CN.737 Fuse box (B) 28 3.0 R
368 612-02 JN.G20 CN.751 Air conditioner 3 7 0.5 P 449 965d-03 JN.G02 CN.737 Fuse box (B) 30 2.0 R
286 451-03 JN.G10 CN.771 Diode unit (opt-F) 3 0.5 P-B
287 451-04 CN.772 Diode unit (opt-R) 3 JN.G10 0.5 P-B 369 612-03 JN.G20 CN.744 Air conditioner 2 4 0.5 P 450 965d-04 JN.G02 CN.737 Fuse box (B) 33 3.0 R
288 451-05 JN.G10 CN.711 Front console CN.402 5 0.5 P-B 370 612-04 JN.G20 CN.713 Front console CN.404 4 0.5 P 451 S1H-01 CN.705 Rear chassis CN.201 16 JN.H02 0.5 L
289 451-06 JN.G10 CN.774 Relay box (B) 13 0.5 P-B 371 615-01 CN.756 CN.746 Themistor assy (outside temp. A/C) 1 0.5 Y 452 S1H-02 CN.725 Opt CAN 4 JN.H02 0.5 L
290 451-07 CN.774 Relay box (B) 28 CN.774 Relay box (B) 13 0.5 P-B 372 616-01 CN.756 A/C operation panel (A) 5 JN.G19 0.5 G-R 453 S1H-03 JN.H05 JN.H02 0.5 L
291 455-01 CN.775 Relay box (C) 23 CN.799 MCZ(C) 11 0.5 R-W 373 616-02 JN.G19 A/C operation panel (A) 6 CN.751 Air conditioner 3 25 0.5 G-R 454 S1H-04 CN.729 Rear view monitor 6 JN.H05 0.5 L
292 456-01 CN.799 MCZ(C) 12 CN.749 Axle oil cooler relay (opt) 1 0.5 Br 374 616-03 JN.G19 CN.746 Themistor assy (outside temp. A/C) 2 0.5 G-R 455 S1H-05 JN.H11 JN.H05 0.5 L
293 457-01 CN.773 Relay box (A) 49 CN.742 Diode unit (ECM2) 2 0.5 P 375 616-04 JN.G19 CN.744 Air conditioner 2 1 0.5 G-R 456 S1H-06 CN.793 MCZ(D) 2 JN.H11 0.5 L
294 458-01 CN.748 Diode unit (ECM1) 1 JN.G12 0.5 O 376 618-01 CN.756 A/C operation panel (A) 7 CN.751 Air conditioner 3 5 0.5 B-Y 457 S1H-09 JN.H11 JN.H14 0.5 L
295 458-02 JN.G12 CN.742 Diode unit (ECM2) 1 0.5 O 377 619-01 CN.756 A/C operation panel (A) 8 CN.751 Air conditioner 3 6 0.5 P-B 458 S1H-10 JN.H14 CN.792 Data link for DIAG (INSITE) 3 0.5 L
296 458-03 CN.773 Relay box (A) 1 JN.G12 0.5 O 378 620-01 CN.756 A/C operation panel (A) 9 CN.751 Air conditioner 3 31 0.5 Y-R 459 S1H-11 JN.H17 JN.H14 0.5 L
297 458-04 JN.G12 CN.775 Relay box (C) 1 0.5 O 379 621-01 CN.756 A/C operation panel (A) 10 CN.751 Air conditioner 3 32 0.5 G-R 460 S1H-12 CN.753 A/C operation panel (B) 10 JN.H17 0.5 L
298 461-01 CN.774 Relay box (B) 23 CN.711 Front console CN.402 15 0.5 L 380 622-01 CN.756 A/C operation panel (A) 11 CN.751 Air conditioner 3 20 0.5 Gr 461 S1H-13 CN.711 Front console CN.402 20 JN.H17 0.5 L
299 462-01 CN.773 Relay box (A) 48 CN.711 Front console CN.402 14 0.5 V 381 623-01 CN.756 A/C operation panel (A) 12 CN.751 Air conditioner 3 16 0.5 O 462 S1L-01 CN.705 Rear chassis CN.201 17 JN.H03 0.5 W
300 471-01 CN.739 Diode unit (load dump 1) 2 CN.774 Relay box (B) 24 0.5 R-W 382 624-01 CN.753 A/C operation panel (B) 1 CN.751 Air conditioner 3 15 0.5 B-L 463 S1L-02 CN.725 Opt CAN 8 JN.H03 0.5 W
301 472-01 CN.764 MAINTENANCE (shortcircuit) 1 CN.764 MAINTENANCE (shortcircuit) 2 0.5 B
383 625-01 CN.753 A/C operation panel (B) 2 CN.751 Air conditioner 3 19 0.5 W-B 464 S1L-03 JN.H06 JN.H03 0.5 W
302 501-01 CN.773 Relay box (A) 39 JN.G41 0.85 L-R
384 626-01 CN.753 A/C operation panel (B) 3 CN.751 Air conditioner 3 14 0.5 B-R 465 S1L-04 CN.729 Rear view monitor 7 JN.H06 0.5 W
303 501-02 JN.G41 CN.710 Front console CN.401 16 0.5 L-R
385 627-01 CN.753 A/C operation panel (B) 4 CN.751 Air conditioner 3 13 0.5 W-R 466 S1L-05 JN.H12 JN.H06 0.5 W
304 501-03 JN.G41 CN.705 Rear chassis CN.201 5 0.85 L-R
386 628-01 CN.753 A/C operation panel (B) 5 CN.751 Air conditioner 3 29 0.5 Lg 467 S1L-06 CN.793 MCZ(D) 3 JN.H12 0.5 W
305 502-01 CN.774 Relay box (B) 34 JN.G33 0.85 R-L
387 629-01 CN.753 A/C operation panel (B) 6 CN.751 Air conditioner 3 30 0.5 G-W 468 S1L-09 JN.H12 JN.H15 0.5 W
306 502-02 JN.G33 CN.711 Front console CN.402 13 0.5 R-L
388 630-01 CN.753 A/C operation panel (B) 7 CN.751 Air conditioner 3 9 0.5 Br-Y 469 S1L-10 JN.H15 CN.792 Data link for DIAG (INSITE) 4 0.5 W
307 502-03 JN.G33 CN.705 Rear chassis CN.201 6 0.85 R-L
389 631-01 CN.753 A/C operation panel (B) 8 CN.751 Air conditioner 3 8 0.5 L-B 470 S1L-11 JN.H18 JN.H15 0.5 W
308 503-01 CN.705 Rear chassis CN.201 7 CN.774 Relay box (B) 19 0.5 W-R
309 505-01 JN.G31 CN.705
390 701-01 CN.705 Rear chassis CN.201 1 JN.G36 0.5 W-B 471 S1L-12 CN.753 A/C operation panel (B) 11 JN.H18 0.5 W
Rear chassis CN.201 4 0.5 Br-W
310 505-02 CN.775 JN.G31 0.5 Br-W
391 701-02 JN.G36 CN.723 Diode unit (key ON power) 1 0.5 W-B 472 S1L-13 CN.711 Front console CN.402 19 JN.H18 0.5 W
Relay box (C) 9
311 505-03 JN.G31 CN.715 0.5 Br-W 392 701-04 CN.739 Diode unit (load dump 1) 1 JN.G36 0.5 W-B 473 S1S-00 CN.705 Rear chassis CN.201 18 JN.H01 0.5 Gr
Side console 1 CN.501 9
312 506-01 CN.705 CN.715 0.5 W-G 393 701-05 JN.G36 CN.745 Diode unit (alternator) 1 0.5 W-B 474 S1S-01 JN.H01 JN.H04 0.5 S
Rear chassis CN.201 3 Side console 1 CN.501 10
313 511-01 JN.G32 CN.705 0.85 G-Y 394 704-01 CN.752 Voltage relay 1 CN.705 Rear chassis CN.201 48 0.85 R-G 475 S1S-02 CN.719 Disconnect (opt CAN) 1 JN.H04 0.5 S
Rear chassis CN.201 28
314 511-02 JN.G32 CN.773 0.85 G-Y 395 705-01 CN.752 Voltage relay 3 CN.774 Relay box (B) 27 0.85 Y-B 476 S1S-03 JN.H07 JN.H04 0.5 S
Relay box (A) 14
315 511-03 JN.G32 CN.711 Front console CN.402 12 0.5 G-Y 396 707-01 CN.721 Joint connector (A) 11 CN.705 Rear chassis CN.201 49 0.85 G-W 477 S1S-04 CN.718 Disconnect (rear view monitor) 1 JN.H07 0.5 S
316 512-01 CN.773 Relay box (A) 9 CN.705 Rear chassis CN.201 25 0.85 Y-B 397 707-02 CN.721 Joint connector (A) 12 CN.750 GPS or GSM 3 0.5 G-W 478 S1S-05 JN.H10 JN.H07 0.5 S
317 514-01 CN.733 Fuse box (A) 31 JN.G11 0.85 Y-R 398 707-03 CN.721 Joint connector (A) 13 CN.711 Front console CN.402 16 0.5 G-W 479 S1S-06 JN.H10 CN.714 Disconnect (MCZ1) 1 0.5 S
318 514-02 CN.782 Column shift lever (lighting) 1 JN.G11 0.5 Y-R 399 707-04 CN.721 Joint connector (A) 14 CN.745 Diode unit (alternator) 2 0.5 G-W 480 S1S-09 JN.H10 JN.H16 0.5 S
319 514-03 JN.G11 CN.711 Front console CN.402 6 0.5 Y-R 400 711-01 CN.775 Relay box (C) 4 JN.G60 0.85 R-W 481 S1S-10 JN.H16 JN.H21 0.5 S
320 514-04 JN.G11 CN.710 Front console CN.401 13 0.5 Y-R 401 711-02 CN.792 Data link for DIAG (INSITE) 2 JN.G60 0.85 R-W 482 S1S-11 JN.H19 JN.H16 0.5 S
321 515-01 CN.733 Fuse box (A) 11 CN.724 Joint connector (B) 11 0.85 P 402 711-03 JN.G60 CN.705 Rear chassis CN.201 13 0.85 R-W 483 S1S-12 JN.H19 CN.716 Disconnect (A/C panel) 1 0.5 S - 15 -
322 515-02 CN.724 Joint connector (B) 12 CN.705 Rear chassis CN.201 8 0.5 P 403 712-01 CN.705 Rear chassis CN.201 22 CN.759 DIAG INC/DEC SW 1 0.5 W-R 484 S1S-13 JN.H19 JN.H20 0.5 S
323 515-03 CN.724 Joint connector (B) 13 CN.710 Front console CN.401 11 0.5 P 404 713-01 CN.773 Relay box (A) 4 CN.705 Rear chassis CN.201 14 0.85 L-W 485 S1S-98 JN.H21 CN.792 Data link for DIAG (INSITE) 5 0.5 B
324 515-04 CN.724 Joint connector (B) 14 CN.715 Side console 1 CN.501 16 0.5 P 405 715-01 CN.705 Rear chassis CN.201 19 CN.788 Emergency throttle 3 0.5 R 486 S1S-99 JN.H20 CN.711 Front console CN.402 1 0.5 Gr
ZW310-5A Floor Wiring Diagram (Side Console 1) CN.508
Back-up
CN.507
alarm
CN.510
Ride control switch (Auto)
1 1
506-01 505-01 3 4 2 000-09 1
W-G Br-W B
To rear console CA001 0.5 0.5 CB001
RC-A
0.5
CN.505 10 9 257-01 7 000-08 515-02
CN.501 L-Y B P
To rear console 1 CN.715 Secondary steering check switch (opt) 0.5 0.5 0.5 5
YAZAKI SDL-2
3 4 2 000-06 1 7183-4000
B
1 000-01 293-01 294-01 295-01 4 0.5
B Gr-L W-G L-B EMS BBZ CN.509
10 9 259-01 7 000-07 515-07
0.85 0.5 0.5 0.5
5 296-01 252-01 249-01 259-01 8 P-W B P Fan reverse switch (Auto/Manual)
0.5 0.5 0.5 5
W-Y W-L Br P-W
0.5 0.5 0.5 0.5
YAZAKI SDL-2 4 515-04 000-15 2 000-17 1
7183-4000 P B B
505-01 506-01 081-01 342-01
RS1 FAN 0.5 0.5 0.5
9 Br-W W-G Y-B G-B 12
0.5 0.5 0.5 0.5 000-19 9 252-01 253-01 000-18 515-03
JN.E01 white tape B W-L L-B B P
341-01 14 257-01 515-01
L-R L-Y P CN.506 10 0.5 0.5 0.5 0.5 0.5 5
13 0.5 0.5 0.5 16 Joint connector (D) (waterproof) YAZAKI SDL-2
7183-4000
251-01 18 19 253-01
Gr L-B 12 10 5 1
17 0.5 0.5 20 000-12 000-11 000-10 000-09 000-08 000-07 000-06 000-05 000-04 000-03 000-02 000-01
CN.511
SUMITOMO DL040 B B B B B B B B B B B B FNR select switch
6188-0494 0.85 0.5 0.5 0.5 0.5 0.5 0.5 0.5 0.5 0.5 0.5 0.85
J-D
515-07 515-06 515-05 515-04 515-03 515-02 515-01 000-16 000-15 000-14 000-13 000-12 3 4 2 000-14 1
P P P P P P P B B B B B B
0.5 0.5 0.5 0.5 0.5 0.5 0.5 0.5 0.5 0.5 0.5 0.85 0.5
FR
24 20 15 13 10 9 000-13 7 249-01 515-06
SUMITOMO 040 B Br P
CN.504 6189-0900 0.5 0.5 0.5 5
Coupler switch (opt) YAZAKI SDL-2
7183-4000
10 9
CN.512
Power mode switch
3 4 2 000-11 1
B
3 6 0.5
342-01 EP
10 9 000-10 7 251-01 515-05
G-B
B Gr P
0.5 0.5 0.5 0.5 5
Top View
2 5
081-01 YAZAKI SDL-2
7183-4000
COUP Y-B CN: Connector, JN: Junction
0.5
From To
Wire Wire
1 4 Wire No.
341-01 CN/JN CN/JN Dia. Color
Pin Pin
L-R No. No.
1 000-01 CN.501 Rear console CN.715 1 CN.506 Joint connector (D) (waterproof) 1 0.85 B
0.5
2 000-02 CN.502 Lift arm auto leveler height kickout SW 3 CN.506 Joint connector (D) (waterproof) 2 0.5 B
8 7
3 000-03 CN.502 Lift arm auto leveler height kickout SW 9 CN.506 Joint connector (D) (waterproof) 3 0.5 B
4 000-04 CN.503 Lift arm auto leveler lower kickout SW 3 CN.506 Joint connector (D) (waterproof) 4 0.5 B
5 000-05 CN.503 Lift arm auto leveler lower kickout SW 9 CN.506 Joint connector (D) (waterproof) 5 0.5 B
CARLING VC1/VC2
CARLING-VC 6 000-06 CN.505 Secondary steering check switch (opt) 1 CN.506 Joint connector (D) (waterproof) 6 0.5 B
7 000-07 CN.505 Secondary steering check switch (opt) 6 CN.506 Joint connector (D) (waterproof) 7 0.5 B
8 000-08 CN.506 Joint connector (D) (waterproof) 8 CN.510 Ride control switch (Auto) 6 0.5 B
9 000-09 CN.510 Ride control switch (Auto) 1 CN.506 Joint connector (D) (waterproof) 9 0.5 B
CN.502 10 000-10 CN.512 Power mode switch 8 CN.506 Joint connector (D) (waterproof) 10 0.5 B
Lift arm auto leveler height kickout SW 11 000-11 CN.512 Power mode switch 1 CN.506 Joint connector (D) (waterproof) 11 0.5 B
4 1 2 12 000-12 CN.506 Joint connector (D) (waterproof) 12 CN.506 Joint connector (D) (waterproof) 13 0.85 B
000-02
B 13 000-13 CN.511 FNR select switch 8 CN.506 Joint connector (D) (waterproof) 14 0.5 B
0.5 14 000-14 CN.511 FNR select switch 1 CN.506 Joint connector (D) (waterproof) 15 0.5 B
HKOS 10 5 6
000-03 294-01 293-01 15 000-15 CN.506 Joint connector (D) (waterproof) 16 CN.509 Fan reverse switch (Auto/Manual) 3 0.5 B
B W-G Gr-L
0.5 0.5 0.5 16 000-16 CN.506 Joint connector (D) (waterproof) 17 JN.E01 0.5 B
YAZAKI SDL-2 17 000-17 CN.509 Fan reverse switch (Auto/Manual) 1 JN.E01 0.5 B
7183-4000
18 000-18 JN.E01 CN.509 Fan reverse switch (Auto/Manual) 6 0.5 B
19 000-19 JN.E01 CN.509 Fan reverse switch (Auto/Manual) 10 0.5 B
20 081-01 CN.504 Coupler switch (opt) 2 CN.501 Rear console CN.715 11 0.5 Y-B
21 249-01 CN.501 Rear console CN.715 7 CN.511 FNR select switch 6 0.5 Br
CN.503 22 251-01 CN.512 Power mode switch 6 CN.501 Rear console CN.715 17 0.5 Gr
Lift arm auto leveler lower kickout SW 23 252-01 CN.509 Fan reverse switch (Auto/Manual) 8 CN.501 Rear console CN.715 6 0.5 W-L
24 253-01 CN.501 Rear console CN.715 20 CN.509 Fan reverse switch (Auto/Manual) 7 0.5 L-B
4 000-04 1 2
25 257-01 CN.501 Rear console CN.715 15 CN.510 Ride control switch (Auto) 8 0.5 L-Y
B
0.5 26 259-01 CN.501 Rear console CN.715 8 CN.505 Secondary steering check switch (opt) 8 0.5 P-W
LKOS 10 5 6
000-05 296-01 295-01 27 293-01 CN.501 Rear console CN.715 2 CN.502 Lift arm auto leveler height kickout SW 7 0.5 Gr-L
B W-Y L-B 28 294-01 CN.501 Rear console CN.715 3 CN.502 Lift arm auto leveler height kickout SW 8 0.5 W-G
0.5 0.5 0.5
YAZAKI SDL-2 29 295-01 CN.501 Rear console CN.715 4 CN.503 Lift arm auto leveler lower kickout SW 7 0.5 L-B
7183-4000 30 296-01 CN.501 Rear console CN.715 5 CN.503 Lift arm auto leveler lower kickout SW 8 0.5 W-Y
31 341-01 CN.504 Coupler switch (opt) 1 CN.501 Rear console CN.715 13 0.5 L-R
32 342-01 CN.501 Rear console CN.715 12 CN.504 Coupler switch (opt) 3 0.5 G-B
33 505-01 CN.501 Rear console CN.715 9 CN.507 Back-up alarm 1 0.5 Br-W
34 506-01 CN.501 Rear console CN.715 10 CN.508 Back-up alarm 1 0.5 W-G
35 515-01 CN.501 Rear console CN.715 16 CN.506 Joint connector (D) (waterproof) 18 0.5 P
36 515-02 CN.506 Joint connector (D) (waterproof) 19 CN.510 Ride control switch (Auto) 5 0.5 P
37 515-03 CN.509 Fan reverse switch (Auto/Manual) 5 CN.506 Joint connector (D) (waterproof) 20 0.5 P
38 515-04 CN.509 Fan reverse switch (Auto/Manual) 4 CN.506 Joint connector (D) (waterproof) 21 0.5 P
- 16 - 39 515-05 CN.512 Power mode switch 5 CN.506 Joint connector (D) (waterproof) 22 0.5 P
33194-48820
40 515-06 CN.511 FNR select switch 5 CN.506 Joint connector (D) (waterproof) 23 0.5 P
41 515-07 CN.505 Secondary steering check switch (opt) 5 CN.506 Joint connector (D) (waterproof) 24 0.5 P
ZW310-5A Floor Wiring Diagram (Side Console 2) CN: Connector, JN: Junction
From To
Wire Wire
Wire No.
CN/JN CN/JN Dia. Color
Pin Pin
No. No.
1 000-01 JN.F01 CN.601 Rear console CN.717 7 0.5 B
2 000-02 JN.F01 CN.616 FNR switch CN.617 4 0.5 B
3 000-03 JN.F01 CN.604 Quick power switch (-) 1 0.5 B
CN.615 CN.602 4 000-04 CN.606 Horn switch (-) 1 JN.F01 0.5 B
Diode unit (L) YAZAKI 62Z
FNR switch (opt)
7222-7740-40 5 000-05 JN.F01 CN.608 Downshift switch1 (-) 1 0.5 B
Gray
4 431-03 081-05 433-03 432-03 1
6 000-06 JN.F01 CN.610 Downshift switch2 (-) 1 0.5 B
10 9
DPV W-R Y-G L-Y Br-Y CN.616 CN.617 7 000-07 CN.611 Hold switch 1 JN.F01 0.5 B
To rear console 0.5 0.5 0.5
YAZAKI 090
0.5 2 1 1 2
6
8 081-01 JN.F04 CN.601 Rear console CN.717 4 0.5 Y-G
3 209-b
7123-7144 244-01 209-a W-L 9 081-02 JN.F04 CN.612 Boom lower kickout detent (float) 2 0.5 Y-G
CN.601 W-L W-L 617-2 10 081-03 JN.F04 CN.613 Bucket leveler detent 2 0.5 Y-G
To rear console CN.717 0.5 616-2 2 000-hc 5
FNR FNR B 11 081-04 JN.F04 CN.614 Boom height kickout detent 2 0.5 Y-G
000-02 246-01 210-a 000-hb 617-4
1 210-b 4 12 081-05 JN.F04 CN.615 Diode unit (L) 3 0.5 Y-G
1 433-01 432-01 3 081-01 4 YAZAKI 090 B Y-B Y-B B
L-Y Br-Y Y-G 7321-9844-30 0.5 0.5 616-3 616-4 Y-B 13 211-01 CN.605 Horn switch (+) 1 CN.601 Rear console CN.717 6 0.5 G-B
0.5 0.5 0.5 617-3
4 YAZAKI 62Z 3 3 4 8 7 14 235-01 CN.611 Hold switch 2 CN.601 Rear console CN.717 8 0.5 G-R
5 211-01 000-01 235-01 8
7123-7740-40
G-B B G-R Gray 15 236-01 JN.F02 CN.601 Rear console CN.717 12 0.5 P-W
0.5 0.5 0.5
RS3 16 236-02 CN.607 Downshift switch1 (+) 1 JN.F02 0.5 P-W
535-01 244-01 536-01 236-01
Br-Y W-L L-Y P-W JN.F05 JN.F06 white tape JN.F03 17 236-03 CN.609 Downshift switch2 (+) 1 JN.F02 0.5 P-W
9 0.5 0.5 0.5 0.5 12
18 244-01 CN.616 FNR switch CN.617 2 CN.601 Rear console CN.717 10 0.5 W-L
246-01 14 258-01 431-01
Y-B R-Y W-R CN.611 19 246-01 CN.616 FNR switch CN.617 3 CN.601 Rear console CN.717 13 0.5 Y-B
13 0.5 0.5 0.5 16 Hold switch
20 258-01 CN.603 Quick power switch (+) 1 CN.601 Rear console CN.717 15 0.5 R-Y
YAZAKI SWP 2 1
7222-7564-40 21 431-01 JN.F05 CN.601 Rear console CN.717 16 0.5 W-R
235-01 000-07
HOLD G-R B 22 431-02 JN.F05 CN.613 Bucket leveler detent 1 0.5 W-R
0.5 0.5
23 431-03 JN.F05 CN.615 Diode unit (L) 4 0.5 W-R
24 432-01 JN.F06 CN.601 Rear console CN.717 2 0.5 Br-Y
YAZAKI 62Z
7123-8520-40 25 432-02 JN.F06 CN.614 Boom height kickout detent 1 0.5 Br-Y
26 432-03 JN.F06 CN.615 Diode unit (L) 1 0.5 Br-Y
27 433-01 JN.F03 CN.601 Rear console CN.717 1 0.5 L-Y
28 433-02 JN.F03 CN.612 Boom lower kickout detent (float) 1 0.5 L-Y
ZW310-5A A/C Control Panel Harness 29

30
433-03
535-01
JN.F03
CN.601 Rear console CN.717 9
CN.615
CN.602
Diode unit (L)
Dual auto leveler (opt)
2
2
0.5
0.5
L-Y
Br-Y
31 536-01 CN.601 Rear console CN.717 11 CN.602 Dual auto leveler (opt) 1 0.5 L-Y
CN.471
To A/C control panel CN.607
5 15 Downshift switch1 (+)
1 624-01 623-01 632-01 621-01 631-01 630-01 S1H-01 S1L-01 10 611-01 613-01 13 625-01 616-01 619-01 17 622-01 618-01 612-01 20 1 236-02 CN.608
B-L O Y-R G-R L-B Br-Y L W P W-G W-B Y P-B Gr B-Y G-R
473-1 472-12 472-9 472-10 473-8 473-7 473-10 473-11 472-4 472-3 473-2 472-5 472-8 472-11 472-7 472-6 CB001
P-W
0.5
Downshift switch1 (-)
013-01 22 628-01 629-01 25 26 627-01 626-01 29 30 31 32 33 34 35 617-01 37 38 39 000-01 1 000-05
Y Lg G-W W-R B-R L-W B B
CB001 0.5
21 472-1 473-5 473-6 473-4 473-3 472-2 473-9 40
013-01 : Wire No. CN.612
Y : Wire color CN.609 Boom lower kickout detent (float)
47x-x : Pin No. of rear console CN.472 or CN.473
ACPA DSS1 Downshift switch2 (+)
CN.610 2 081-02 433-02 1
To rear console 1 236-03
P-W Downshift switch2 (-) FL Y-G L-Y
CB001 0.5 0.5 0.5
1 red tape
000-06
CN.473 B
To rear console CN.753 CB001 0.5 YAZAKI 62Z
DSS2 7123-8520-40
1 624-01 625-01 626-01 627-01 4 CN.613

B-R
B-L
2
W-B
14 28
W-R
27
Bucket detent
628-01 629-01 630-01 631-01 JN.F02 JN.F01
ACB Lg G-W Br-Y L-B CN.605 2 081-03 431-02 1
5 23 24 7 6 8
HORN Horn switch (+) BL Y-G W-R
000-01 S1H-01 S1L-01 12 0.5 0.5
Black tape B L W
1 211-01 CN.606 blue tape
9 40 8 9 G-B Horn switch (-)
CB001 0.5
YAZAKI SWP YAZAKI 62Z
1 000-04 7123-8520-40
7123-7923-40
B
QICP CB001 0.5 CN.614
CN.603 Boom height kickout detent
Quick power switch (+)
CN.472 1 2 081-04 432-02 1
258-01
To rear console CN.756 R-Y BKO Y-G Br-Y
CB001 0.5 CN.604 0.5 0.5
yellow tape
1
Quick power switch (-)
013-01 617-01 613-01 611-01 4
Y L-W W-G P YAZAKI 62Z
1 000-03 7123-8520-40
21 36 12 11
5 8 B
616-01 612-01 618-01 619-01 CB001 0.5
Y G-R B-Y P-B CN.602
ACA 15 20 19 16 Dual auto leveler (opt)
631-01 621-01 622-01 623-01
Y-R G-R Gr O 2 1
9 4 5 18 3 12 1 2
535-01 536-01
SUMITOMO DL090
6195-0149 JN.F04 DAL Br-Y L-Y
0.5 0.5
7123-1424-40 7222-1424-40
013-01 : Wire No. Gray Gray
Y : Wire color CLIP: MITSUBISHI CABLE
21 : Pin No. of A/C CN.471 PP021-55120
- 17 -
33194-49230
ZW310-5A Hydraulic Circuit Diagram Multiple control valve Pump control valve
(Port size)
P: SAE1 High
Steering pilot (Port size) A1,A2,B1,B2: SAE1
T1,T2: SAE1 1/4
valve (Orbitrol) P T All: 3/4-16UNF
T3: SAE1/2
Bucket cylinder
Ps,SY,DY: G1/4
Pa1,Pb1,Pa2,Pb2,Tdr: G3/8 Ps
(ROLLBACK)
185x 110x510 G3/8 G3/8
Rear axle
RAISE
L R Overload
relief valve (Port size)
32.5 MPa All: SAE1 Front axle
at 50 L/min
80
DUMP
3 B2
cm /rev G3/8 G3/8
Stop valve Bucket spool A2
Stop valve Check valve
(Port size) (slow return valve) Lift arm (boom) cylinder Pressure
A,B: G3/8 (with orifice 1.2) 145x 95x930
DR: G1/4 b2 a2 sensor
A B B A (Port size) Pressure switch (declutch)
Flow rate (stop lamp)
UP
All: SAE 3/4
control SY
valve
09701-04840
DR DR
DOWN
5.4 MPa
B1 G1/4
SWA A SWB B
DY
Steering Steering cylinder Steering A1 G1/4 Ride control valve
accumulator 70x 45 x 542 accumulator Check valve
(Port size) G1/2 (slow return (option)
Capacity: 0.2 L
TS G1/4
Capacity: 0.2 L valve) b1 a1
Pi B A
Gas pressure: Gas pressure: (with orifice 1.2)
8.0 MPa 8.0 MPa
Overload
relief valve Check valve
36.8 MPa (slow return TA PA PB
TS
T3 at 50 L/min valve)
G1/4 Orifice T2
(with orifice 1.0)
Orifice A B
( 1.5) Main relief
( 1.5) Lift arm spool 0.2 MPa
at 5 L/min Brake valve
valve
T1 SP2 (Port size)
29.4 MPa PA,PB,A,B,TB: G3/8
P at 290 L/min Ride control TA: G1/2
accumulator SWA: M16
SWB: G1/4
34.3 MPa (option)
Pb at 50 L/min Tdr Capacity: 5 L T
Pa Gas pressure: 3 MPa
Dr
Steering valve T
(Port size)
A,B,P,T: G3/4
Pa,Pb: G3/8
LS P
(b2)1 2(a2) 4.9 MPa
Service brake accumulator
LS: G1/4 DUMP RAISE
(Rollback)
Secondary steering Steering pressure
pump unit (option) switch (option) Capacity: 1.4 L
(b1)3 4(a1) Pressure Gas pressure: 6.8 MPa Pressure sensor
Secondary steering pump DOWN UP sensor G3/8 G3/8 (for service brake
pressure sensor (option) Secondary steering (lift arm raise) G3/8 ACCF G3/8 ACCR
pressure alarm)
MF MR
block (option) (Port size) (option)
P,1~4: G1/4 G3/8 G3/8
P T T: G3/8
4.9 MPa G3 49 MPa
Pilot valve G1/4 Charge relief
S4
valve
P Charging block
M 10 G1/2
cm3/rev
LS CF EF Pump Device Pressure sensor Pilot shutoff valve
Cut in: 11.8 MPa
Cut out: 14.7 MPa
29.4 MPa (pilot primary pressure) (hydraulic lock)
Brake
Line priority Parking brake
(Priority valve) filter valve
Pi2
Fan motor Cooling fan Pilot relief
Torque control
solenoid valve valve
Pg DR G1/2
1 1/16- 1 1/16-
Pressure 12UN
33.1 12UN 3.7 MPa
Pi1
sensor cc/rev at 40 L/min PS1 G3/8
(pump output
pressure) Dr
9/16- X
PS2 G1/4
ST Dr 18UNF G1/4 Pressure
DR2 G1/4
4.9 MPa
sensor
S3 (parking brake)
D
G1/4
14.4 MPa at 26 L/min Hydraulic oil PB G3/8
(Pump regulator) cooler Pilot
170 16.8 Parking brake accumulator
M SAE1 STD
solenoid
ACCP
Check valve
3 3
cm /rev cm /rev
Fan pump assy G1 1/2 PP G3/8

(Main pump) Sg M 44.5
(Port size)
Sp 3
cm /rev (accessory pump G1
EF: G1 1/4 mounted on engine) Breather valve
Sp: SAE 2 1/2 (Pilot pump) 0.3 0.06
G1 1/4 MPa Capacity: 0.75 L
CF,Sg,Dr: G3/4 G1 1/2 G1
D: G1/2
Gas pressure: 2 MPa
Pg,LS,ST,Pi1,Pi2: G1/4 10 m
Hydraulic tank SAE2
4.0kPa 50.0kPa
=2.0
10
Relief valve
- 18 - (return filter
bypass) Return
Suction strainer 177 m 0.15 0.02 MPa filter
09701-04840

TTNFC EN 00 - Circuit

Uploaded by

Copyright:

Available Formats

TTNFC EN 00 - Circuit

Uploaded by

Document Information

Original Title

Copyright

Available Formats

Share this document

Share or Embed Document

Sharing Options

Did you find this document useful?

Is this content inappropriate?

Copyright:

Available Formats

TTNFC EN 00 - Circuit

Uploaded by

Copyright:

Available Formats

DIAGRAMS

Electrical Connection Diagram (1/2) ......................................................................................... 2

(961) [W] FA9 YB

[R]15 [R]20 (R)(361) R BW (RW)(598) LW(713)

Air conditioner unit

(965-f) (BW) Parking solenoid (407)

Backup alarm Radio power ON Radio

Relay Box-A Relay Box-B Relay Box-C

458 A1 0 425 A6 0 21 B1 202 33 B6 451 458 C1 0 81 C6 222

CAB front Pilot shut-off

422 A2 0 426 A7 0 406 B2 409 416 B7 0 21 C2 405 C7

421 A3 0 415 A8 0 33 B3 451 882 B8 225 425 C3 0 C8

High beam Turn (R)

81 A4 215 15 A9 211 62 B4 206 83 B9 231 426 C4 0 C9 Wiper Relay

81 A5 208 11 A10 462 11 B5 461 83 B10 232 68 C5 455 C10

Monitor ICF MC A/C INSITE monitor OPT CAN ECM 0

YAZAKI SWP 000-10

CN: Connector, JN: Junction

3 000-03 CN.006 Front combination lamp (L)(GND) 1 CN.015 GND 1 1.25 B

GND (rear) 000-10

To rear console CN.103 CN.104

CN: Connector, JN: Junction

Front wiper relay (Lo) SUMITOMO MICRO-ISO-RELAY CN.408 2 612-01 611-01 1

JN.G31 JN.G32 JN.G33

124-04 129-01 123-04 134-01

Black SUMITOMO DL040

To floor rear console

To floor rear console (2/5)

2 1 CN.752 4 7 515-01 808-01 021-01 033-01 065-01

YAZAKI CN 017-01 032-01 812-01 813-01 15 16 17 18 19 20

IDC 0.5 0.5 Data link for DIAG (INSITE)

CN.776 24 000-r04 511-02 512-01 713-01

Diode unit (parking brake) B G-Y Y-B L-W

(Rear Console) (5/5) Wire

ZW310-5A A/C Control Panel Harness 29

1 624-01 625-01 626-01 627-01 4 CN.613

Fan pump assy G1 1/2 PP G3/8

You might also like