Study On The Medium Effect For The Growth Rate of Spirulina, Arthrospira
Study On The Medium Effect For The Growth Rate of Spirulina, Arthrospira
Study On The Medium Effect For The Growth Rate of Spirulina, Arthrospira
Study on the medium effect for the growth rate of Spirulina, Arthrospira
platensis in natural seawater
To cite this article: U S T Aung 2020 IOP Conf. Ser.: Earth Environ. Sci. 420 012004
U S T Aung*
Marine Science Department, Pathein University, Myanmar
Abstract. Spirulina, Arthrospira platensis, is the most important microalgae for the
production of biomass as health food for human and animal food. In this experiment, the
growth rates of A. platensis were tested at seven different media (F-2 with CaCO3, F-2 with
NaHCO3, Z-1 with CaCO3, Z-1 with NaHCO3, Z-2 with NaHCO3, urea and T-super with
NaHCO3, and PES with NaHCO3) at pH 9 to 10 and salinity 30‰. The culture was started at
the optical density (OD) 0.20 and the experimental period was ended after 10 days in the
laboratory room. Among the media urea and T-super with sodium bicarbonate were recorded
the best. The optimum growth of A. platensis (OD 0.69) was observed in urea and T-super with
sodium bicarbonate. In addition, urea and T-super with sodium bicarbonate gave rise to the
maximum growth of A. platensis and then followed by Z-1 medium with NaHCO3 and PES
medium with NaHCO3. The minimum OD 0.44 was recorded in F-2 medium by using CaCO3.
The results of present investigation revealed the potential use of seawater with some nutrients
for laboratory culture of A. platensis.
1. Introduction
Spirulina, A. platensis, was the dominance of life on earth for more than 3.5 billion years ago. The
name “Spirulina” is derived from the Latin word for “helix” or “spiral” denoting the physical
configuration of the organism when it forms swirling, microscopic stands [1].
Spirulina is not a nitrogen-fixing cyanobacteria (blue-green algae) [2]. It has a long history of safe
human consumption, known to be safe and nutritious. It can play an important role in human and
animal nutrition, environmental protection through wastewater recycling and energy conservation [2,
3]. Spirulina is rich in proteins (60-70%), vitamins and minerals used as protein supplement in diets of
undernourished poor children in developing countries [2]. One gram of Spirulina protein is equivalent
to one kilogram of assorted vegetables [4].
The length of cell is 125-225 μm and the cell’s width is 25-30 μm. Ends of trichomes are not or
very slightly attenuated, terminal cells broadly rounded. Cells of trichomes are 10-12 μm in diameter
and 2-5 μm long. The filaments are motile, gliding along their axis and have no heterocyst.
Reproduction is accomplished by fragmentation of a mature trichome into many shorter segments
through destruction of specialized multiple intercalary cells.
There are about 1.386 x 1012 (one trillion three hundred eighty-six billion) cubic meters of water on
Earth. About 97% of it is in the oceans and seas. Of the remaining water, about 3% is freshwater.
Nearly 70% of that freshwater is frozen in icecaps of Antarctica and Greenland. Most of the remainder
is present as soil moisture or lies in deep underground aquifers not accessible to human use. Of the 1%
Content from this work may be used under the terms of the Creative Commons Attribution 3.0 licence. Any further distribution
of this work must maintain attribution to the author(s) and the title of the work, journal citation and DOI.
Published under licence by IOP Publishing Ltd 1
SCESAP 2019 IOP Publishing
IOP Conf. Series: Earth and Environmental Science 420 (2020) 012004 doi:10.1088/1755-1315/420/1/012004
freshwater, agriculture (including irrigation) uses 70%, industry 20% and other 10% including
drinking water for 7 billion people. In the year 2025 at least 2.5 billion people won’t have enough
water to drink [5]. So, we will have to use seawater for agriculture.
Spirulina media contain generally high concentrations of nutrients that impact their cost [6]. The
cost of nutrients is considered to be a major factor for A. platensis biomass production [7]. The
advantages of A. platensis production in seawater medium are: (i) lower fertilizer cost; (ii) saving
farmland by using waste sea beach; (iii) seawater culture is not easily polluted by heavy metals and
contaminations. The utilization of seawater media for the cultivation of A. platensis will be reduced
the production cost considerably [8].
High pH and temperature are the key factors for large scale A. platensis culture indoors. The
optimum temperature for A. platensis culture is in the range of (28-33°C) [9]. A. platensis is a
cyanobacterium growing at elevated pH. In addition A. platensis requires relatively high pH values
(9.5 to 11.0 with an optimum at 10.5) and is, therefore, less subject to contaminations [10]. A.
platensis is the edible microorganisms which grow naturally in tropical regions inhabiting alkaline
lakes containing sodium carbonate or sodium bicarbonate other materials and a source of fixed
nitrogen of tropical and subtropical regions. These lakes are found near volcanoes or even within the
caldera of the volcano [11].
In nature lakes of the world, the limited supply of nutrients usually regulates growth cycles. New
nutrients come from an upwelling from inside the earth, when rains wash soils into the lakes, or from
pollution. The alga grows rapidly and reaches a maximum density, and then dies off when nutrients
are exhausted. A new seasonal cycle begins when decomposed algae release their nutrients or when
more nutrients flow into the lake [12, 13]. Zarrouk (1966) introduced the famous alkaline medium to
enable the analysis of natural habitat [14]. The nutrient source for A. platensis is nitrate. However,
Stanca and Popovici [5] proved that the use of urea as source of nutrient was increased the A. platensis
biomass production.
Spirulina was known to grow naturally in the Lake Bodu (Chard, Africa), Lake Chad (Chard,
Africa), Lake Johann (Chard, Africa), Lake Rombu (Chard, Africa), Lake Aranguadi (Chard, Africa),
Lake Elementia (Ethiopia, Africa), Lake Nakuru (Kenya, Africa) Lake Rudolf (Kenya, Africa), Lake
Taung Pyauk (Myanmar, Asia), Lake Twyn Ma (Myanmar, Asia), Lake Twyn Taung (Myanmar,
Asia), Lake Ye Kharr (Myanmar, Asia), Lake Chenghai (China, Asia), Lake Texcoco (Mexico, North
America) and Lake Buccacina (Peru, South America [15]). This present study aims to observe the best
media for A. platensis culture and to provide good ideas for mass cultivation in natural seawater and to
give knowledge local people to cultivate A. platensis for domestic economy.
2
SCESAP 2019 IOP Publishing
IOP Conf. Series: Earth and Environmental Science 420 (2020) 012004 doi:10.1088/1755-1315/420/1/012004
3
SCESAP 2019 IOP Publishing
IOP Conf. Series: Earth and Environmental Science 420 (2020) 012004 doi:10.1088/1755-1315/420/1/012004
3. Results
pH 9.0
0.2
pH 9.5
0.15
0.1 pH 10.0
Figure 1. Comparison of the
0.05 growth of A. platensis in
0 three different pH values by
1 2 3 4 5 6 7 8 9 10 11 using F-2 medium with
Days CaCO3.
4
SCESAP 2019 IOP Publishing
IOP Conf. Series: Earth and Environmental Science 420 (2020) 012004 doi:10.1088/1755-1315/420/1/012004
0.5
0.45
0.4
0.35
0.3
OD
0.25 pH 9.0
0.2 pH 9.5
0.15
0.1 pH 10.0 Figure 2. Comparison of
0.05 the growth of A. platensis
0 in three different pH values
1 2 3 4 5 6 7 8 9 10 11 by using F-2 medium with
Days NaHCO3.
0.5
0.4
OD
0.3 pH 9.0
0.2 pH 9.5
pH 10.0 Figure 3. Comparison of the
0.1
growth of A. platensis in
0 three different pH values by
1 2 3 4 5 6 7 8 9 10 11 using Z-1 medium with
Days CaCO3.
5
SCESAP 2019 IOP Publishing
IOP Conf. Series: Earth and Environmental Science 420 (2020) 012004 doi:10.1088/1755-1315/420/1/012004
0.7
0.6
0.5
0.4
OD
pH 9.0
0.3
pH 9.5
0.2
pH 10.0 Figure 4. Comparison of the
0.1
growth of A. platensis in
0 three different pH values by
1 2 3 4 5 6 7 8 9 10 11 using Z-1 medium with
Days NaHCO3.
pH 9.0
0.3
pH 9.5
0.2
pH 10.0 Figure 5. Comparison of the
0.1
growth of A. platensis in
0 three different pH values by
1 2 3 4 5 6 7 8 9 10 11 using Z-2 medium with
Days NaHCO3.
For three different pH tested, pH 10 in Z-2 medium with NaHCO3 was found doubling time
superior to other pH values (pH 9.0 and pH 9.5). The doubling times were observed on 4 th day of the
experimental period in pH 10.0 and 5th day in other pH. The maximum OD 0.61 was reached in pH
10.0 within 10 days of the experimental period.
In this experiment, the reducing time did not occur during the culture period. The growth increased
and doubling time was observed faster with increasing pH. From this result, pH 10.0 was suitable for
production of A. platensis in small volume culture.
6
SCESAP 2019 IOP Publishing
IOP Conf. Series: Earth and Environmental Science 420 (2020) 012004 doi:10.1088/1755-1315/420/1/012004
In pH value 9.5, A. platensis growth was gradually increased within the experiment and nearly
double time was observed 4th day of the experiment. The maximum OD 0.67 was reached within 10
days of the experiment. The color was dark-green at the end of the culture.
In pH value 10.0, the growth of A. platensis was gradually increased and over doubling time was
observed 5th day of the experiment. The color was dark-green and the maximum OD 0.69 was reached
within 10 days of the experiment.
In this experiment, A. platensis grew up the culture end. Over doubling times started from day 5. If
the pH value was increased, the growth of A. platensis was also increased. This experiment suggested
that A. platensis may be to survive in high pH values.
0.7
0.6
0.5
0.4
OD
pH 9.0
0.3
pH 9.5
0.2
pH10.0 Figure 6. Comparison of the
0.1
growth of A. platensis in
0 three different pH values by
1 2 3 4 5 6 7 8 9 10 11 using Urea and T-super
Days medium with NaHCO3.
pH 9.0
0.3
pH 9.5
0.2
pH 10.0 Figure 7. Comparison of the
0.1
growth of A. platensis in
0 three different pH values by
1 2 3 4 5 6 7 8 9 10 11 using PES medium with
Days NaHCO3.
7
SCESAP 2019 IOP Publishing
IOP Conf. Series: Earth and Environmental Science 420 (2020) 012004 doi:10.1088/1755-1315/420/1/012004
0.8
0.6
OD
0.4
0.2
0
F-2 with F-2 with Z-1 with Z-1 with Z-2 with Urea & PES with
CaCO3
CaCO3 NaHCO3
NaHCO3 CaCO3
CaCO3 NaHCO3
NaHCO3 NaHCO3
NaHCO3 T-super NaHCO3
NaHCO3
with
NaHCO3
NaHCO3
Figure 8. Comparison of the growth of A. platensis in various nutrients with pH (9.0, 9.5,
10.0) of salinity 30‰ at the end of the culture.
The effect of media and pH on growth of A. platensis at the end of the culture was shown in Figure
8. A. platensis survived in various pH and media. The highest growth was found at pH 10 and urea and
T-super medium. Therefore, the yield of A. platensis is influenced by pH and medium.
Richmond and Grobbelaar [10] observed that the optimal pH for the growth of A. platensis was
10.5. Mahadevaswamy [16] said that the yield of A. platensis could decrease when pH values were
decreased.
Florian et al. [17] and Yean-Chang C [18] reported that the best medium to reduce the cultural cost
and increase the biomass of A. platensis cultures was modified by Zarrouk’s medium. Dineshkumar et
8
SCESAP 2019 IOP Publishing
IOP Conf. Series: Earth and Environmental Science 420 (2020) 012004 doi:10.1088/1755-1315/420/1/012004
al. [19] stated the highest yields of A. platensis culture by using Zarrouk’s medium and F-2 medium
were found on 30th day and 21st day as 1.86 dw/L and 0.52 dw/L, respectively.
Table 6. The growth of A. platensis in various nutrients with pH (9.0, 9.5, 10.0) at
salinity 30‰.
Days
Media pH
8 9 10
9.0 OD 0.34 OD 0.34 OD 0.31
F-2 with CaCO3 9.5 OD 0.36 OD 0.35 OD 0.33
10.0 OD 0.41 OD 0.38 OD 0.37
9.0 OD 0.39 OD 0.36 OD 0.32
F-2 with NaHCO3 9.5 OD 0.43 OD 0.41 OD 0.38
10.0 OD 0.47 OD 0.45 OD 0.44
9.0 OD 0.51 OD 0.49 OD 0.43
Z-1 with CaCO3 9.5 OD 0.51 OD 0.47 OD 0.46
10.0 OD 0.52 OD 0.48 OD 0.45
30‰ of Salinity 9.0 OD 0.48 OD 0.52 OD 0.55
Z-1 with NaHCO3 9.5 OD 0.51 OD 0.54 OD 0.57
10.0 OD 0.57 OD 0.60 OD 0.62
9.0 OD 0.49 OD 0.51 OD 0.53
Z-2 with NaHCO3 9.5 OD 0.55 OD 0.57 OD 0.59
10.0 OD 0.57 OD 0.59 OD 0.61
9.0 OD 0.54 OD 0.57 OD 0.60
Urea and T-super with NaHCO3 9.5 OD 0.55 OD 0.60 OD 0.67
10.0 OD 0.57 OD 0.61 OD 0.69
9.0 OD 0.53 OD 0.55 OD 0.56
PES with NaHCO3 9.5 OD 0.58 OD 0.60 OD 0.62
10.0 OD 0.57 OD 0.59 OD 0.61
9
SCESAP 2019 IOP Publishing
IOP Conf. Series: Earth and Environmental Science 420 (2020) 012004 doi:10.1088/1755-1315/420/1/012004
dw/L on 18th day [22] of cultivation. Natural seawater fortified with different amounts of NaHCO 3 and
NaNO3 did not show significant impact on Spirulina growth. In this study, A. platensis was also
survived in seawater and growth contained NaHCO 3 in media was flourished during cultural period.
In F-2 and Z-1 media, the growth rate of A. platensis was found that content of sodium bicarbonate
media was higher than containing calcium carbonate media in seawater. From this study, using sodium
bicarbonate into culture media may be one of the important factors for A. platensis growth. Calcium
carbonate rapidly raised the pH values but the responding growth of A. platensis was not achieved to a
suitable rate in seawater media. Sodium bicarbonate was suitable to use in seawater because it slowly
increased the pH values and nearly steadied at the required pH.
Florian et al. [17] used a modified Zarrouk’s medium to reduce Spirulina production cost. The
modified Zarrouk’s medium was diluted up to five times without impacting the growth rates in 28-
days batch cultivation. Higher dry weights (1.21 g/L and 0.84 g/L) were observed after 21 days of
batch cultivation. In the present study, maximum growth rates in modified Zarrouk’s medium were
observed on 10th day in pH 10.0.
S. platensis could grow well in the modified Zarrouk (Z9) and Provasoli’s enriched seawater (PES)
media were re-modified into five media by adding varying concentrations of NaCl, NaHCO 3, and
seawater (salinity). The Z9 medium provided the best growth rate at the end of culture and the PES
medium provided the best at the initial days [18]. In the present study, both modified Zarrouk’s and
Provasoli’s enriched seawater (PES) media provided the best growth rates at the end of the culture.
Z-1 medium which was absent of Mg(NO3)2.6H2O nutrient was higher the growth of A. platensis
than Z-2. The problem with seawater is the high level of Calcium and Magnesium ions which
precipitate out the low level of Phosphorus in seawater, a vital component that must be supplied to
promote microalgae growth. To counteract this precipitation of Phosphorous and other elements, most
of these authors and other researchers have used large quantities of sodium or potassium carbonate to
precipitate the Calcium and Magnesium as carbonates [4].
In all media urea and T-super obtained the highest growth rate and followed by PES medium and
Z-1. This may be the effect of feeding method. In this experiment urea and T-super were fed daily. So,
the plants obtained the nutrients for growth. In other culture media, the increasing growth rates
gradually slow down due to the exhausted nutrients. With an increase in age of culture, cell density
increased, light penetration decreased, the new cells may absorb nutrient leading depletion of nutrient
in the culture as well as the medium leading to reduction of growth. Therefore, age and medium have a
substantial effect on the culture.
PES and Z-1 media are suitable for culturing in seawater but the treatments of A. platensis are
expensive. Others, Z-2 and F-2, are not suitable to use in seawater culture because the growth rates of
A. platensis in them were poor and the costs are expensive. Therefore, urea and T-super medium was
the most suitable medium in seawater.
It may be concluded that urea and T-super medium was the most suitable medium in seawater for
the best growth of A. platensis because the nutrients are cheaper than other media. Therefore A.
platensis culture with pH 10.0 at salinity 30‰ by using urea and T-super medium was the most
suitable condition in natural seawater. The results were to provide good ideas for mass cultivation in
natural seawater.
Acknowledgments
The author greatly appreciates Rector and Pro-rectors of Pathein University for their kind permission
to do this research work. I also greatly thank to Dr. Cherry Aung, Professor, and Head of Marine
Science Department, Pathein University for supporting. Special thanks go to Dr. Htay Aung, Professor
(Retired) and U Min Oo, Lecturer, Marine Science Department of Pathein University for his
suggestions and necessary help.
References
[1] Hill G 1980 The secret of Spirulina (California: University of Tree Press) p 218
10
SCESAP 2019 IOP Publishing
IOP Conf. Series: Earth and Environmental Science 420 (2020) 012004 doi:10.1088/1755-1315/420/1/012004
[2] Gershwin M E and Belay A 2007 Spirulina in Human Nutrition and Health ed Taylor and
Francis Group, an informa business (Boca Raton London New York) p 312
[3] Vincent W F and Silvester W B 1979 Wastewater as a source of algae Water Research 13 717-
719
[4] Usharani G, Saranraj P and Kanchana D 2012 Spirulina Cultivation: A Review International
Journal of Pharmaceutical & Biological Archives 3(6) 1327-1341
[5] Raoof B, Kaushik B D and Prasanna R 2006 Formulation of a low-cost medium for mass
production of Spirulina Biomass and Bioenergy 30(6) 537-542
[6] Provasoli L 1968 Media and products for the cultivation of marine algae Culture and
Collections of Algae, ed Watanabe A and Hattori A (Tokyo) 63-75
[7] Vonshak A 1997 Spirulina platensis (Arthrospira) Physiology, Cellbiology and Biotechnology
(Taylor and Francis: London) 131-158
[8] Wu B, Tseng C K and Xiang W 1993 Large-scale cultivation of Spirulina in seawater-based
culture medium. Bot. Mar. 36 99-102
[9] Vonshak A, Ablovich S, Boussi S A and Richmond A 1982 Production of Spirulina Biomass,
Effects of Environmental Factors and Population Density Biomass 2(3) 175-185
[10] Richmond A and Grobbelaar J U 1986 Factors affecting the output rate of Spirulina platensis
with reference to mass cultivation Biomass 10 253-264
[11] Akter N, Noor P, Jahan M A and Hossain M 1996 Spirulina culture in Bangladesh Comparison
of rice husk ash and sodium bicarbonate as source of carbon feedback in Spirulina culture
Bangladesh Journal of Science and Industrial Research 31 137-146
[12] Henrikson R 2010 Spirulina World Food (Ronore Enterprises, Inc., Hana, Maui, Hawaii) p 187
[13] Fox R D 1996 Spirulina production and potential (Aix-en-Provence: Edisud) p 232
[14] Zarrouk C 1996 Contributioná l’étude d’une cyanophycée. Influence de divers facteurs
physiques et chimiques sur la croissance et la photosynthésede Spirulina maxima [Ph.D.
Thesis] (Paris: Ecole des Hautes Etudes en Sante Publique, Universitéde Paris)
[15] May Y K 2007 Productivity and quality control of Spirulina platensis Biomass Culture on
Commercial Scale in Myanmar [Ph.D. Thesis] (Myanmar: Department of Botany, Mandalay
University)
[16] Mahadevaswamy M and Venkataraman L V 1987 Bacterial contaminants in blue green alga
Spirulina produced for use as biomass protein. Archiv. For Hydrobologie 10(4) 623-630
[17] Florian D, Emilie A, Lagia M, Clément G, Gatien F, Amaury P, Pierre R, Martin P and Jean-
François S 2017 Optimization of Arthrospira platensis (Spirulina) growth from laboratory
scale to pilot scale fermentation 3(59) 1-14
[18] Yean-Chang C 2011 The effect of shifts in medium types on the growth and morphology of
Spirulina platensis (Arthrospira platensis) Journal of Marine Science and Technology 19(5)
565-570
[19] Dineshkumar R, Narendran R and Sampathkumar P 2016 Cultivation of Spirulina platensis in
different selective media Indian Journal of Geo Marine Sciences 45(12) 1749-1754
[20] Richmond A, Hkarg S and Boussiba S 1982 Effect of bicarbonate and carbondioxide on the
competition between Chlorella vulgaris and Spirulina platensis Plant and cell physiology 23
1411-1417
[21] Khin M S 2009 Studies on the culture of Spirulina platensis (Nordstedt) Geitler using seawater
medium [Thesis] (Myanmar: Department of Marine Science, Mawlamyine University)
[22] Bharat G, Abhishek N, and Beena P 2011 Cultivation of Spirulina species in different liquid
media J. of Algal Biomass Utln 2(3) 15-26
11