CONTENTS

1.

X - RAY RADIATION PRECAUTION 1

2.

SAFETY PRECAUTION . 1

3.

PRODUCT SAFETY NOTICE . . 2

4.

THE ALIGNMENT FLOW CHART . . 3

5.

INSTALLATION AND SERVICE ADJUSTMENTS 3

6.

USA CHANNEL FREQUENCY TABLE (181 CH) . . . 9

7.

WIRING DIAGRAM . . . 12

8.

BLOCK DIAGRAM . . . . . 13

9.

IC BLOCK DIAGRAM . . . . 14

10. TDA9850 BLOCK DIAGRAM . . . . 15

11. COMPONENT AND BOTTOM VIEW . . . . 16
12. SCHEMATIC DIAGRAM . . . . 23
13. ELECTRICAL PARTS LIST . . . . 24

CAUTION: BEFORE SERVICING THE CHASSIS, READ THE X-RAY RADIATION

PRECAUTION SAFETY PRECAUTION ON PAGE 1 AND PRODUCT
SAFETY NOTICEON PAGE 2 OF THIS MANUAL.

X-RAY RADIATION PRECAUTION

1. Excessive high voltage can produce potentially hazardous X - RAY RADIATION. To avoid such
hazards, the high voltage must not be above the specified limit. The normal value of the high
voltage of this receiver is 27.5kV at zero beam current (minimum brightness) under a 120V AC
power source. The high voltage must not, under any circumstances, exceed 30kV.
2. Each time a receiver requires servicing, the high voltage should be checked following the HIGH
VOLTAGE CHECK procedure in this manual. It is recommended the reading of the high voltage
be recorded as a part of service record. It is important to use an accurate and reliable high voltage
meter.
3. This receiver is equipped with a Fail Safe (FS) circuit which prevents the receiver from
producing an excessively high voltage even if the B+ voltage increases abnormally. Each time the
receiver is serviced, the FS circuit must be checked to determine that the circuit is properly
functioning, following the FS CIRCUIT CHECK procedure in this manual.
4. The primary source of X - RAY RADIATION in this TV receiver is the picture tube. For
continuous X - RAY RADIATION protection, the replacement tube must be exactly the same type
tube as specified in the parts list.
5. Some parts in this receiver have special safety-related characteristics for X - RAY RADIATION
protection. For continuous safety, parts replacement should be undertaken only after referring to
the PRODUCT SAFETY NOTICE below.

SAFETY PRECAUTION
WARNING:
Service should not be attempted by anyone unfamiliar with the necessary precaution on this
receiver. The following are the necessary precautions to be observed before servicing this chassis.
1. Since the power supply circuit of this receiver is directly connected to the AC power line, an
isolation transformer should be used during any dynamic service to avoid possible shock hazard.
2. Always discharge the picture tube anode to the CRT conductive coating before handling the
picture tube. The picture tube is highly evacuated and if broken, glass fragments will be violently
expelled. Use shatter proof goggles and keep picture tube away from the unprotected body while
handling.
3. When replacing a chassis in the cabinet, always be certain that all the protective devices are put
back in place, such as: non-metallic control knobs, insulating covers, shields, isolation
resistor-capacitor network etc.
4. When replacing parts or circuit boards, disconnect the power cord.
5. When replacing a high wattage resistor (oxiode metal film resistor) on the circuit board, keep the
resistor 10mm (1/2in) away from circuit board.
6. Connection wires must be kept away from components with high voltage or high temperature.
7. If any fuse in this TV receiver is blown, replace it with the FUSE specified in the chassis parts
list.

-1-

8. Before returning the set to your customer, always perform an AC leakage current check on the
exposed metallic parts of the cabinet, such as antennas, terminals, screwheads, metal overlays,
control shafts etc. to be sure the set is safe to operate without danger of electrical shock. Plug the
AC line cord directly into a 120V AC outlet (do not use a line isolation transformer during this
check). Use an AC voltmeter having 5000 ohms per volt or more sensitivity in the following
manner:
Connect a 1500 ohm 10 watt resistor, paralleled by a 0.15F, AC type capacitor, between a known
good earth ground (water pipe, conduit, etc.) and the exposed metallic parts, one at a time. Measure
the AC voltage across the combination of 1500 ohm resistor and 0.15 F capacitor. Reverse the
AC plug at the AC outlet and repeat AC voltage measurements for each exposed metallic part.
Voltage measured must not exceed 0.3 volts RMS. This corresponds to 0.2 milliamp. AC. Any
value exceeding this limit constitutes a potential shock hazard and must be corrected immediately.

PRODUCT SAFETY NOTICE

Many electrical and mechanical parts in the chassis have special safety-related characteristics.
These characteristics are often passed unnoticed by a visual inspection and the X-RAY
RADIATION protection afforded by them cannot necessarily be obtained by using replacement
components rated for higher wattage, etc. Replacement parts which have these special safety
characteristics are identified in this manual and its supplement electrical components having such
features are shaded on the schematic diagram and the parts list.
Before replacing any of these components, read the parts list in this manual carefully. The use of
substitute replacement parts which do not have the same characteristic as specified in the parts list
may create shock, fire, X-RAY RADIATION or other hazards.

-2-

THE ALIGNMENT FLOW CHART

PIF

B+, AGC,H-frequency

To fit the front cabinet,

external degaussing

Preheat for 30 minutes

Factory itemsadjustment

Focus

White

Heatrun for 2 hours

balance

re-alignment,

focus,

high

voltage,

To fit the back cabinet

X-ray protection test, sound power test, CCD, V-chip,

BTSC, secret code setting, AV function check.

Control buttons, channels, white balance, sound, hit the set

INSTALLATION AND SERVICE ADJUSTMENTS

GENERAL
In the majority of cases, a color television receiver will need only slight touch-up adjustment upon
installation. Check the basic characteristics such as FSEHV and focus. Observe the picture for
good black and white details without objectionable color shading. If color shading is evident,
demagnetize the receiver.
If color shading still persists, perform purity and convergence adjustments. This should be all that is
necessary to achieve optimum receiver performance.
FOCUS ADJUSTMENT
Adjust the FOCUS control (on T471) for well defined scanning lines on the picture screen.
HIGH VOLTAGE CHECK
CAUTION: These is no HIGH VOLTAGE ADJUSTMENT on this chassis. Checking should be
done following the steps below.
1. Connect an accurate high voltage meter to the second anode of the picture tube.
2. Turn on the receiver. Set the BRIGHTNESS and CONTRAST controls to minimum (zero beam
current).
3. High voltage will be measured about 27.5kV.
4. Vary the BRIGHTNESS control to both extremes to be sure the high voltage does not exceed the
limit under any conditions.
FS CIRCUIT CHECK
The Fail Safe (FS) circuit check is indispensable for the final check in the servicing. Checking
should be done following the steps below.

-3-

1. Turn the power switch on and adjust customer controls for normal operation.
2. Temporarily short R412 on the Main Board with a jumper wire. Raster and sound will
disappear.
3. The receiver must remain in this state even after removing the jumper wire. This is the evidence
that the FS circuit is functioning properly.
4. To obtain a picture again, temporarily turn the receiver off and allow the FS circuit more than 30
seconds to reset. Then turn the power switch on to produce a normal picture.
Troubleshooting Guide for Fail Safe Circuit
Check that the set returns to normal operation when pin
34 of N101 on the Main Board is grounded with jumper
YES

NO

Check if the voltage across capacitor

Faulty
NO

C411 is approximately 21V.

Power Circuit or Horizontal Circuit

YES
Defective Fail Safe Circuit

PIF alignment
1) Apply DC 12V to output pin of N551(pin3 of N551 ) , connect pin7 of LA76814(N101)
to GND.
2) Apply 95dB, 45.75MHz RF signal to the tuner's IF pin through a 1000P ceramic
capacitor. Connect the DC voltameter'spole to LA76814 pin 47 , pole to GND.
Note: For LA76814 ES01 version, the voltameter'spole should connect to pin50 .
3) Adjust T202 with a non-inductive screwdriver until the reading on the DC voltameter is DC
3.6V0.01V.

B+ CHECK
1) Prepare the test equipment.
2) Use the DC voltameter at DC 200V position to test VD551, i.e. B+.
3) Connect the power plug to AC 120V/60Hz, turn on the power switch, wait for normal raster,
then adjust RP551 to make B+ = 130V0.5V.

Test point

VD551

VD556

VD554

VD555

DC(V)

130

25

15

18

-4-

TEST EQUIPMENT
1) DC regulated power supply PAB18-1.8
2) Audio voltameter
3) Oscilloscope
4) High-voltage meter
5) Digital multimeter
6) AC voltameter

TEST MODE SET(CHECK)

TEST MODE ADJUSTMENT INSTRUCTION
TEST MODE adjustment is a special adjustment which is controlled by I2 C BUS. The TV set has
been set at optimum mode at the factory. Except for special need, such as replacing CRT
MEMORYIC etc., it is hoped not to adjust it. To conduct TEST MODE's adjustment, please do it
according to the following steps:
There are two special romote controller for the set. One is "Under Adjustment" and the other is
"Under Adjustment for W/B Balance".
1) Press "PROD" button to enter the FACTORY, B/W BALANCE, ADJUST or SETUP mode.
2) In B/W BALANCE mode, select the item you want to adjust directly by pressing the button on
the"Under Adjustment for W/B Balance" remote controller and use the "ADJ+" or "ADJ-" button
to adjust. You can press "ADJUP" or "ADJDOWN" to select needed adjustment item and use
the "ADJ+" or "ADJ-" button to adjust too.
3) In ADJUST mode, select the item you want to adjust directly by pressing the button on the "Under
Adjustment" remote controller and use the "ADJ+" or "ADJ-" button to adjust. You can press
"ADJUP" or "ADJDOWN" to select needed adjustment item and use the "ADJ+" or "ADJ-"
button to adjust too.
4) In SETUP mode, select the item you want to adjust by pressing the button "ADJUP" or
"ADJDOWN" on the "Under Adjustment". Then use the "ADJ+" or "ADJ-" button to adjust.
adjust.
5) Press "PROD" to exit the TEST MODE.

H-blanking, H-center adjustment

1) Receive test signal, enter into the ADJUST mode.
2) Select the H.BLK.LEFT and H.BLK.RIGHT item, adjust the level to make the H -blanking
amount on the left and right screen at an appropriate position.
3) Select the H.PHASE item, adjust the level to make the left and right picture sysmmetrical.

H-Size, E/W correction

Receive test signal, adjust RP302 to make Horizontal size right, and adjust RP301 to make E/W correction
right.

V-amplitude, linearity, S-correction, center adjustment

1) Receive test signal, enter into the ADJUST mode. adjust the value to make V-center and the CRT's
2) Select the V.POS item , adjust the value to make V-center and the CRT's geometric center is in
accordance. Then select the V.SIZE item, adjust the value to make the overscan is less than or

-5-

Equate 10% .
2) Select the V.LINE item, adjust the value to make the upper and lower grid's(on the screen) vertical
distance equal. Select the V.SC item, adjustthe value to make the vertical distance from upper
grid to middle screen is equal to the vertical distance from lower grid to middle screen.
3) Repeat the above steps 2) &3) to make the V-center, V-amplitude, V-linearity at the optimum
mode.

White balance, sub-brightness adjustment

1) Receive test signal, enter into B/W BALANCE mode with the special remote controller of
"Under Adjustment for B/W BALANCE".
2) Set the value of item as the following table:
Name
S-BRI
R-BIA
G-BIA
B-BIA
R-DRV
G-DRV
B-DRV
C.B/W

Default
65
7
65
0

Value
0~127
0~255
0~255
0~255
0~127
0~15
0~127
0~3

Description
Sub Brightness
Red Bias
Green Bias
Blue Bias
Red Drive
Green Drive
Blue Drive
Cross B/W

3) Set the value of S-BRI=85, then press "LINE" button. Adjust the SCREEN potentiameter
clockwise until a slight bright horizontal line appears on the screen. Adjust the value of
R-BIA, G-BIA and B-BIA, until the line change white. Press "LINE" button again. Then
decrease S-BRI to a proper value.
4) Press "LINE" button to exit B/W BALANCE mode.

ADJUST MENU LIST

Receive test signal, enter into ADJUST mode with the special remote controller of
"Under Adjustment".
Item
00*
01**
02**
03**
04*
05*
06*
07*
08**
09**
10**
11**
12
13
14
15

Name
H.PHASE
NT.H.PHASE
H.BLK.LEFT
H.BLK.RIGHT
V.SIZE
V.LINE
V.POSI
V.SC
NT.V.SIZE
NT.V.LINE
NT.V.POSI
NT.V.SC
RF.AGC
VOL.OUT
OSD.H.POSI
OSD.V.POSI

Description
H.PHASE

Vertical Size
Vertical Linearity
Vertical DC
Vertical S-Correction

RF AGC Delay
Volume Control

-6-

Value
0~31
0~31
0~7
0~7
0~127
0~31
0~63
0~31
-32~+31
-16~+15
-32~+31
-16~+15
0~63
0~127
0~127
0~31

Default
13
00
7
0
82
3
33
6
00
00
00
00
30
127
11
16

16
17
18
19
21
22

0~15
0~63
0~63
0~63
0~31
0~63

INPUT LEVEL
SPECTRAL
WIDE BAND
STEREO
FILTER SET
SAP VCO

7
0
0
63
63
63

Note: 1.All the items sign with "*" can adjust to different value for different
TV set.
2.All the items sign with "**" do not affect the IC of La76814.
ADJUST MENU LIST
Receive test signal, enter into ADJUST mode with the special remote controller of
"Under Adjustment".
Description
Item
Name
0:LA76814; 1:LA76812
00
LA76814/LA76812
01
SAP IC SELECT 0:TDA9850; 1:CXA2104; 2:TDA9855; 3:UPC1851B
SUB.CONT
Subcontrast(0~31)
02
03
SUB.COLOR
Subcolor(0~63)
04
SUB.SHARP
Subsharpness(0~31)
05
SUB.TINT
Subtint(0~63)
Black Stretch Definition(0:on; 1:off)
BLK.STR.DEF
06
AFC GAIN
AFC Gain(0:low; 1:high)
07
Vertical Synchronization Separate Sense(0:low; 1:high)
V.SETUP
08
CD.MODE
09
Count Down Mode(LA76814:0/1;LA76812:0~7)
Digital OSD(0:Analog; 1:Digital)
DIGITALOSD
10
11
OSD CONT
OSD Contrast(0~127)/LA76814(0~3)
Gray Mode(0/1)
GRAY MOD
12
Blue Selection(0~3)
B.GAMSEL
13
14
Red&Green Definition(0/1)
RG.GAM.DEF
FBPBLK.SW
15
FBPBLK.SW(0/1)
Bright.Abl.Threshold(0~7)
16
BRIGHT ABL.TH
Emg.Abl.Def(0/1)
EMG.ABL.DEF
17
18
BRT.ABL.DEF
Brt.Abl.Def(0/1)
MID.STP.DEF
19
Mid.Stp.Def(0/1)
20
R-Y/B-Y G.BL R-Y/B-Y Gain Balance(0~15)(None for)(LA76814)
R-Y/B-Y Angle(0~15)
R-Y/B-Y ANG
21
C.KILL.OFF
C_Kill OFF(0/1)
22
Sound Trap(0~7)
SND.TRAP
23
Volume Filter Defeat(0/1)
24
VOL.FIL
Video IF(0:45.75M;1:58.75M)
VIF.SYS.SW
25
Video Level(0~7)
VIDEO.LEVEL
26
FM Level(31)
FM.LEVEL
27
0:Twice On; 1:Memory; 2or3:Once On
POWER OPT
28
29
POWER FLAG 0:No Power On Screen;1:Power On Screen
SEARCH CHECK 0:No Power On Search;1:Power On Search
30
0:Slow;1:Quick
31
SEARCH SPEED
AV
Input
(0:No; 1:1; 2:2; 3:3)
32
AV OPTION
33
POSITION L/R Position of CH Number(0:Upper Left;1:Upper Right)
34
BLUE BACK
Blue Back When No Signal(0:Off; 1:On)
35
BLACK BACK Black Back When Switch Channel(0:Off;1:On)

-7-

Default
0
0
15
31
15
31
1
1
1
0
1
2
0
2
0
0
0
0
0
0
8
8
0
3
1
0
7
16
1
0
1
0
2
1
1
0

36
37
38
39
40
41
42
43
44
45
46
47

Stereo Option(0:off;1:on)
STEREO OPTION
0:Woofer;1:Headphone
WOOFER/H.PHONE
WOOFER VOL.OPT Volume of H.Phone(0:No Woofer;1:Woofer)
Sensitivity Function(0:off;1:on)
SENSITIVITY
Cut
Video
Out Before Power Off(0:on; 1:off)
V.MUTE P.OFF
CCD Function(0:off; 1:on)
CCD OPTION
V-CHIP Function(0:off; 1:on)
V-CHIP OPTION
Password of V-CHIP(0:off;1:on)
PASSWORD OPT
COMB.OPTION
Y/C Separate Function(0:off;1:on)
0:TDF-3M3;1:PHOLIPUV1336B
TUNER OPTION
Game Option(0:on; 1:off)
GAME OPTION
SCREEN OPTION 0:No Screen;1:Screen When Power On;2:ScreenWhen Power Off;3:Screen When Power On/Off

-8-

1
0
0
0
0
1
1
1
0
1
1
0

USA CHANNEL FREQUENCY TABLE

U.S.A. Channel
PIF 45.75MHZ, CIF 42.17MHZ, SIF 41.25MHZ.
UNIT:MHZ
Channel fp(picture) fs(sound)
2
55.25
59.75
3
61.25
65.75
4
67.25
74.75
5
77.25
81.75
6
83.25
87.75
7
175.25
179.75
8
181.25
185.75
9
187.25
191.75
10
193.25
197.75
11
199.25
203.75
12
205.25
209.75
13
211.25
215.75
14
471.25
475.75
15
477.25
481.75
16
483.25
487.75
17
489.25
493.75
18
495.25
499.75
19
501.25
505.75
20
507.25
511.75
21
513.25
517.75
22
519.25
523.75
23
525.25
529.75
24
531.25
535.75
25
537.25
541.75
26
543.25
547.75
27
549.25
553.75
28
555.25
559.75
29
561.25
565.75
30
567.25
571.75
31
573.25
577.75
32
579.25
583.75
33
585.25
589.75
34
591.25
595.75
35
597.25
601.75

-9-

Channel
36
37
38
39
40
41
42
43
44
45
46
47
48
49
50
51
52
53
54
55
56
57
58
59
60
61
62
63
64
65
66
67
68
69

fp(picture) fs(sound)
603.25
607.75
609.25
613.75
615.25
619.75
621.25
625.75
627.25
631.75
633.25
637.75
639.25
643.75
645.25
649.75
651.25
655.75
657.25
661.75
663.25
667.75
669.25
673.75
675.25
679.75
681.25
685.75
687.25
691.75
693.25
697.75
699.25
703.75
705.25
709.75
711.25
715.75
717.25
721.75
723.25
727.75
729.25
733.75
735.25
739.75
741.25
745.75
747.25
751.75
753.25
757.75
759.25
763.75
765.25
769.75
771.25
775.75
777.25
781.75
783.25
787.75
789.25
793.75
795.25
799.75
801.25
805.75

USA CHANNEL FREQUENCY TABLE

U.S.A. CATV Channel
PIF 45.75MHZ, CIF 42.17MHZ, SIF 41.25MHZ.
UNIT:MHZ
Channel fp(picture) fs(sound)
1
73.25
77.75
2
55.25
59.75
3
61.25
65.75
4
67.25
74.75
5
77.25
81.75
6
83.25
87.75
7
175.25
179.75
8
181.25
185.75
9
187.25
191.75
10
193.25
197.75
11
199.25
203.75
12
205.25
209.75
13
211.25
215.75
14
121.25
125.75
15
127.25
131.75
16
133.25
137.75
17
139.25
143.75
18
145.25
149.75
19
151.25
155.75
20
157.25
161.75
21
163.25
167.75
22
169.25
173.75
23
217.25
221.75
24
223.25
227.75
25
229.25
233.75
26
235.25
239.75
27
241.25
245.75
28
247.25
251.75
29
253.25
257.75
30
259.25
263.75
31
265.25
269.75
32
271.25
275.75
33
277.25
281.75
34
283.25
287.75
35
289.25
293.75
-10-

Channel
36
37
38
39
40
41
42
43
44
45
46
47
48
49
50
51
52
53
54
55
56
57
58
59
60
61
62
63
64
65
66
67
68
69
70

fp(picture) fs(sound)
295.25
299.75
301.25
305.75
307.25
311.75
313.25
317.75
319.25
323.75
325.25
329.75
331.25
335.75
337.25
341.75
343.25
347.75
349.25
353.75
355.25
359.75
361.25
365.75
367.25
371.75
373.25
377.75
379.25
383.75
385.25
389.75
391.25
395.75
397.25
401.75
403.25
407.75
409.25
413.75
415.25
419.75
421.25
425.75
427.25
431.75
433.25
437.75
439.25
443.75
445.25
449.75
451.25
455.75
457.25
461.75
463.25
467.75
469.25
473.75
475.25
479.75
481.25
485.75
487.25
491.75
493.25
497.75
499.25
503.75

USA CHANNEL FREQUENCY TABLE

U.S.A. CATV Channel
PIF 45.75MHZ, CIF 42.17MHZ, SIF 41.25MHZ.
UNIT:MHZ
Channel fp(picture) fs(sound)
71
505.25
509.75
72
511.25
515.75
73
517.25
521.75
74
523.25
527.75
75
529.25
533.75
76
535.25
539.75
77
541.25
545.75
78
547.25
551.75
79
553.25
557.75
80
559.25
563.75
81
565.25
569.75
82
571.25
575.75
83
577.25
581.75
84
583.25
587.75
85
589.25
593.75
86
595.25
599.75
87
601.25
605.75
88
607.25
611.75
89
613.25
617.75
90
619.25
623.75
91
625.25
629.75
92
631.25
635.75
93
637.25
641.75
94
643.25
647.75
95
91.25
95.75
96
97.25
101.75
97
103.25
107.75
98
109.25
113.75

-11-

Channel
99
100
101
102
103
104
105
106
107
108
109
110
111
112
113
114
115
116
117
118
119
120
121
122
123
124
125

fp(picture) fs(sound)
115.25
119.75
649.25
653.75
655.25
659.75
661.25
665.75
667.25
671.75
673.25
677.75
679.25
683.75
685.25
689.75
691.25
695.75
697.25
701.75
703.25
707.75
709.25
713.75
715.25
719.75
721.25
725.75
727.25
731.75
733.25
737.75
739.25
743.75
745.25
749.75
751.25
755.75
757.25
761.75
763.25
767.75
769.25
773.75
775.25
779.75
781.25
785.75
787.25
791.75
793.25
797.75
799.25
803.75

- 12 -

BLOCK DIAGRAM

A101
TUNER

CPU N701
LC863232A

IR RX

IR TX
MU28P0381

Z201
SAWF

MEMORY
N702
AT24C04

VIDEO
OUT

N101

PIF

SIF

LA76814
DEFLECTION

VIDEO

FM

CHROMA

VIDEO

OUT

IN1

IN2

AUDIO
IN

SWITCH
TC4053BP/BF

BTSC
TDA9850

OUT

IN

VIDEO
IN

R
G
B

V OUT
N451
LA7841

B3
16V

B1
130V

T471
FBT

B2
18V

POWER
V513
2SC4237

AUDIO
AMP
LA4287

B8
25V

CRT
DRIVE

H OUT
V432
3DD2553

AUDIO
OUT

CRT

AC 120V
NTSC

- 13 -

LA76814 IC BLOCK DIAGRAM

AudioOutput
FMOutput
PIFAGCFilter
RFAGCOutput
PIFInput1

PIF Input2

2.5

2.5

2.4

2.53

1.93

2.56

2.11

2.8

2.3

2.8

4
4

IFGround
5V

3.7

IFVcc
FMFilter
AFTOutput
BusData

GreenInput

BlueInput
Fast BlankingInput
RGB Vcc
Red Output
Green Output
Blue Output

B.AKBInput

2.34

2.53

4.8

2.7

5V

3.52

2.4

1.1

0
2.32

1.15

3.06
1.13

Ext.AudioInput.
FLLFilter
VCOCoil1

VCOCoil2
APCfilter

BlackLevelDetector
InternalVideo Input(S_CIN)
Video/VerticalGround
External Video Input(Y IN)
Video/Vertical/BUSGround

SelectedVideoOutput
ACCFilter

2.64

3.58MHzCrystal

0.53

fsc(3.58MHz)Output

3.16

3.3

3.16

0.35
0

3.05
0

Vertical
Output

2.51

RAMPALC
Filter

2.63

ChromaAPC1Filter
KillerFilter
X-RAY

HolizontalGround

2.9

OSDContrast

NC

Holizontal/Bus
Vcc

5V

HolizontalAFC
Filter

2.63

1.7

0.48

1.11

Holizontal
Output

SIFOutput

VideoOutput

4.8

RedInput

SIFAPCFilter

2.18

2.12

BusClock
ABL

SIFInput

NC

- 14 -

VCOIREF
FBPInput

composite
baseband
input
+
C1

11

C2

13

R1

C3

14

C15

C4
+

15

C5

C17

16

26

Q1

17

ceramic
resonator

R2
R3
C14
C13

3 1

NOISE
DETECTOR

STEREODECODER

INPUT
LEVEL
ADJUST

C16

SAP
DEMODULATOR

L+R

30

STEREO/SAP
SWITCH

31

L-R/SAP

CR

20

STEREO
ADJUST

29 25

+
C12 C11 C10 C9 CL

32

DBX
2

onlyduring
adjustment

10

12

18

C7

19

DEMATRIX
+
MODE
SELECT

C18

24

SDA

SCL

LOGIC,ICTRANSCEIVER

DE-EMPHASIS

C6

C19

Vref

SUPPLY

VC C V CAP

27

21

22

23

28

OUTL

OUTR

C8

stereo
mono
SAP
to
audio
processing

SAPwithoutDBX

MAD

MHA010

- 15 -

COMPONENT VIEW OF MAIN BORAD

- 16 -

COMPONENT VIEW OF KEY BORAD

- 17 -

COMPONENT VIEW OF INDICATOR BORAD

- 18 -

COMPONENT VIEW OF CRT BORAD

- 19 -

COMPONENT VIEW OF BACK AV BORAD

- 20 -

COMPONENT VIEW OF LATERAL AV BORAD

- 21 -

COMPONENT VIEW OF STEREO BORAD

- 22 -

W801
X

XS802

VHS

R817
82

C812
0.01

R825
82

R819
1K

B7
5V

+
8

B6
12V
Rin

B6
12V

C13
47nF
R02
RJ8.2K

R03 C14 C15

C16
RJ160 50V10 100nF 50V4.7
+

Cnr

Cm

Cdec

6
AGND

R21
100

7
DGND

R20
100

SDA

SCL

C01
C19
50V10 16V100

12

C00
16V100

R01
2.2K

C03
50V4.7

C02
470nF
13

14

C04
220nF

15

Cw

Cs

Ctw

Cts

MAD

OUTL
Cnd

Vref

Cl

Vcc

COMP
Csde

SAP

Vcap
OUTR

Cp1

Cp2

Cph

Z COM

OZ

INH
32
31
30
29

28

27

26
24

25

Cr
20

Cmo

Css
19
18

CER

22

17
LA4285(L)

OX

1X
A

VEE

VSS
C

15

13
12
GND

INT

EXT
SW

VOL
FLI

NFB

GND
OUT

VCC

GND
INT

EXT

SW

VOL

FLI

NFB

N01

GND

B6
12V

OUT

VCC

7
R621
680

14

11

10
9
1
2
+

5
6
7

10

2
+

9
8

+ C606
35V1000

C607
0.01

B2
18V

C625
25V470
C615
25V/470

R615
2.2K

B3
12V

XP602
TJC3-2Y

B902
10W8OHM

B901
10W8OHM

CRT BOARD

XP902
L901
SCN-5Y
X
5

N451
LA7841

C451
35V100

+ C931
16V10

INPUT

NON INPUT

R931
1K
R932
15K

R933
1.5K

C933
16V10

R904
330

R914
330

R924
330

GND

R452
1

VD452
1Z75

R453
12K

L441
AC41

R441
1/2SJ1K

R472
1FJ1

C438
2000MJ7800

R902
100

C901
CJ680

C903
CJ56R

R912
100

C911

CJ680

C913
CJ56R

R922
100

C923
CJ56R

C921
CJ680

V931
2SA1015

VD933
1N4148

XP901
SCN-4Y

R456
12K

10

V902
DA4544

VD901
1N4148

R906
560

V912
DA4544

VD911
1N4148
R916
680

V922

R926
680

XP903
TJC2-2A

VD921
1N4148

DA4544

R940
33

C458
100FK0.1

+ C457
25V2200

R461A
1/2DJ120

+ C450
16V100

SCREEN

FOCUS

HV

VD474
EU1

R491
1FJ3.3

R460
2W270

R457
39K

+ C456
50V1

R458
1K

R474
1FJ1

10

V303
3DD3852

R313
2W4.7

L301
600uH

B3
12V

R928
1/2SJ2.7K

R918
1/2SJ2.7K

R908
1/2SJ2.7K

6
8
9

U901

JG0034

R907
2SJ10K

R917
2SJ10K

R927
2SJ10K

FO

64SX502 Y22-DC02

W902

XS901
GZS10-2-AC2DG

11

10

K6D

XS402
TJC2-5A

XP402
TJC2-5Y

XS401

SCN-4Y

2
1

C939
2KV1000

+ C474
250V22

R233
1/2W1.5K

C231
50NP1

6.This circuit diagram covers a basic or

representative chassis only.There may be
some comonents or partial circuit differences
between the acutal chassis and the circuit
diagram.

1.All resistance values are in ohms.K represents

K ,M represents M .
2.The rated power of all resistance is 1/6W
unless otherwise noted.
3.All capacitance values without unit are in F.
represents F,n represents nF.
4.The rated voltage of all capacitance is 50 V
unless otherwise rated.
5.Product safety should be considered when a
component replacement is made in any area of
receiver.The values of components indicated
by a mark in this circuit diagram have special
signficance to product safety. It is particularly
recommended that only the parts specified in
service manual be used for components
replacement pointed out by the mark.

NOTICE:

R232
10K

T471
BSC29-0142B
TP-H
TEST

TP-G
TEST

R459
1SJ1

ABL

C459
100FK0.1

VD435
RU4DS

VD436
RU4C

C305
160V33

R314
1/2SJ560

R312
DJ5.6K

C315
1000

VD301
D

+ C306
35V470

V302
2SA1015

B4
24V

R310
2.7k

R311
2.7K

R455
12K

V932
2SC1815

C932
16V10

R935
39

R900
DJ10K

C934
50V0.47

OUTPUT

C455
500FK10

C437
400NJ0.033

R308
100K

R309
56K

B1
130V

VD472
EU2

+ C454
50V1

C453
1000

R454
3K

L442

R442

+ C444
160V4.7

C435

L433
Z2073

R446
220K

VCC1

VD451
EM01Z

V432
3DD2553

L432
ZZ008

H-W
RP302
B-10K

R307
2.2K

2000MJ6800

C472 +
35V100

R451
5.6K

C452 +
35V1000

C441
200FK0.36

R451A
1WR

XS403
SCN-5

B4
24V

R434
2W270

B4
24V

XP601
TJC3-3Y

B8
25V

PCC
RP301
B-50K

L431
ZZ008

+ C434
50V10

T431
JDT1904

R306
39K

C304
FK0.1

C432
500KK1000

C433
500KK3900

R433
1/2SJ1K

R304
10K

V301
2SC1815

R305
1K2

VCC2

R432
J
C431
X

R302
100K

C303
FK0.1

R303
270K

V431
2SC2383-O

H-PULSE

XS601
TJC3-3A

XS602
TJC3-2A

C616
25NP1

R625
2.2K

C626
25NP1

B6
12V

+ C301
35V47

R301
8.2K

PUMP OUT

00

R403
+
C408 330K
50V0.47

R404
820

VD621
1N4148

+ C623
VD622
16V100 1N4148

R630
10K

VD631
1N4148

V631
2SA1015

16V100

+ C622

TDA9850

B503F58

Q01

C05
50V10

R00
39

Cadj

21

23
+ CR +
+
+
C07
C21
C06
50V10 50V2.2 50V4.7 50V4.7

C627
0.01

R127
220

C212
50V1

VD402
1N4148

VD411
EU1

R411A
1/2W3.3
C411
35V47

VD401
1N4148

C631
16V/100

R631
10K

V632
2SC1815

R122
330

C140
470
T101

R412
8.2K

R205
22K

R206
47K

C203
16V4.7

R202
1.2K

C208
50V0.47
VD412
HZ7C1
R415
3.9K

R275
3K

N602

C08
15nF

C621
16V10

VD620
1N4148
+ C628
16V/2.2

R778
560

C125
18

R121
1K

R204
560K

C206
16V47

R207
2M

+ C210
16V0.47

C139
50V0.47

C124
50V1

R632
10K

+ C733
16V/10

+ C137
50V0.47

+ C136
50V1

C123
1000

L121
15UH

C126
39

R777
8.2K

V633

R128
X

R201
1K

C204
50V1
C205
0.01

G201
S3.58

C412
50V1

R274
4.7K

VD412
UZ8.2BSB
R413
15K

16

X COM

16
52

53

51
50
49
48
47
46

44

45

42

43

41

C209
J

C274
0.01

C207
FK0.01

R268
1K

R414
10K

C276
16V10

C279
0.01

R409
680

R273
4.7K

R272
3K

R499
4.7K

11

VDD

+
EXT VIDEO IN

40
39
38
37

2SC1815

+
+
C20 +
CL
C18
C17
50V10 100nF 50V2.2 16V100

R611
680

GND (V/C/B)

54

VD612
1N4148
VD611
1N4148

VCO FIL

ABL

SEL VIDEO OUT

FSC OUT

36
35
34
33
32
31
30
29
28

10

1Z
LA4285(R)

C12 + C11 + C10 + C09 +

50V1 50V1 50V10 50V10

N601

+ C617
0.01

VD610
1N4148

16V100

+ C613

16V100

+ C612

N101
LA76814

SIF OUT

SIF APC FIL

SIF IN
FM OUT

VCO COIL

EXT AUDIO IN
VIF IN1

VCO COIL
APC FIL
VIDEO OUT

INT VIDEO IN

BLK STRETCH FIL

R IN

VCC (V/C/D)

G IN

ACC FIL

VCC (RGB)

APC1 FIL

XTAL

R OUT

X-RAY

KILLER FLT

BLANK IN

B IN

CLOCK

DATA

AFT OUT

FM FIL

VCC (VIF)

GND(IF)

VIF IN2

RF AGC

PIF AGC

AUDIO OUT

R780
+ C734 560
16V/10

C618
16V/2.2

C611
16V10

R779
8.2K

R116
100

1
2
3
4
5
6
7
8
9

Y COM
R622
1K

R620
3K

V601
2SC1815

C122
X

C116
0.01

C120
FK0.022

C121
X

VEI

0Y
R610
3K
R612
1K

B7
5V
RP601
B10K

R602
1K

VEO

1Y
R107
X

B3
12V
R119
1K

Lin

Lout

Rout

C111
X

L101
0.68UH

R744
220

R110
X

+
6

R108
X

Z101
D45U

C119
0.01

V803
2SC1815

C720
0.01

VCC

SCL

GND

5
R745
220

C112
0.01

38M

C115
16V100

C117
50V1

10
11
12
13
14
15
16
17
18

G OUT

GND (CCD/H)

B OUT
AKB IN

OSD CONTRAST
VCC (CCD)

V OUT

VCO IREF

CLOCK OUT

RAMP ALC.FIL
VCC (H)

FBP IN

H AFC FIL
H OUT

R806
47K

R816
8.2K

R815
4.7K

R820
3.3K

VD801
1N4148

R824
27K

C804
0.01

R765
22K

B5
5V

A701
HS-0038

N702
AT24C08

+ C719
16V47
1
2
3
4
SDA

V102
X

R111
X

L102
22UH

R120
3.3K

C118
0.01

C245
0.01

19
20
21
22
23

26

24
L401
TEM2011
25
C499
4700P

27

R805
C811
16V10

C813
16V10

R764
22K
R763
22K
R762
2.2K
R761
22K
R760
10K
R759
22K
R758
22K
R757
22K
R766
100
R756
22K
R755
22K

R753
22K
R751
22K
R749
22K
R747
22K

R743
3.3K

C110
X
R109
X

B7
5V

R113
100K

R114
100K
R241
100
R242
100

+ C244
16V47

R244
2.7K

R401
2.2K
C405
0.01

R402
3.3K

C406
FK0.068

C404
16V220

C403
FK0.47
+

C402
FK0.22

R243
270

C401
50V0.47
+

Rout

XS801-1
AV2

R814
47K

4.7K
C810
16V10

42
41
40
39
38
37
36
35
34
33

R754
10K

R742
3.3K
R740
4.7K
R738
4.7K

B6
12V

AUDIO
R400
1/2DJ270

C407
50V1

R811
4.7K
R813
4.7K
C809
16V10
R818
82

COMB-FILTER
V-MUTE

AV1

AV/TV

AV2
MUTE

SRS ON/OFF

WOOFER ON/OFF

IR
NC
32
31
30
29
28
27
26
25
24
23
22
R736
4.7K

B1
130V

VD552
1N4148

RL552
OMIT-SS-112M

R555
1/2DJ47K

R556
22K

N551

R561
10K

AN7812

R563
3W39
V552
2SC1815

B5
5V

R812
47K

C808
16V10

N801
TC4053BP/BF

LNA
50/60
ALARM
W-VOL
VOL-L
VOL-R
POWER
NC
GND
XTAL1
S-VHS

SCL1

SAFTY

SDA1
SCL0

NC

SDA0

BLANK
B OUT
G OUT
R OUT

R552
1/2DJ100K

R567
1.2K

R554
150K
VD561
HZ6C3

2SB892S

V554

V553
2SC1815
R553
4.7K

R566
10K

N553
AN7805

C570
10V470
R408
2.2K

R810
47K

C814
16V10

1
2
3
4

C772
KK470
7

5
C771
KK470
6

8
9
10
11
XTAL2
VDD
KEY IN
AFT IN
NC
NC
RESET
FILT

N701
LC863232A

B8
25V

RP551
B-2K

VD551
C561
R551
RU4AM 200V220 2SJ47K

C551
2KV470

C566
50V220

R569
1FJ2.2

+ C564
25V1000

B2
18V
R568
2SJ1.5K

SDA

XS803
AV1

C806
16V10

R809
4.7K
C807
16V10

68K

R823

B5
5V
R746
22K
R748
22K
R735
10K

R770
100

R774
100

R709
390K
12
13
14
15
16
17
18

CVBS-IN
V SYNC
H SYNC

10

C556
1KV470

VD556
ES1
C554
1KV470

VD554
RU4AM

R562
2FJ1

VD555
EU2

C565
25V2200

N552
AN7805

B7
5V

R807
82
R808
82

C801
16V220

R835
27K

R836
68K
+

R772
10K

R775
10K

G701
32K

C702
0.01

B3
12V

R837
220
C824
50V1

B7
5V

C802
0.01

B6
12V

R773
12K

R776
12K

+
19
20
21

T511
BCK-50-04
3

11

12

14

R838
100

V803
2SC1815

C825
16V10

B3
12V

R832
68K

V802
R831
2SC1815 27K

R833
220

C822
50V1

R801
27K

R802
68K

R101
33K

C803
50V1

5V

R102
100K

C705
18P

C703
0.01

L701
39UH
C704
15P
+ C701
16V47

R708
10K

R725
330
+
C713
16V1

R726
270K

C714
16V2.2

C516
1KV2200P
R525
5W6.8
7

V513
2SC4706
1

13

R834
100
C823
16V10

R803
220

B3
12V

V801
2SC1815

C805
16V470

IF

5V

R104
100

33V

SCL

R1705
2.7K

R1706 R1707
1.5K
680

+ C103
50V2.2

R103
1K

R105
100

SDA

NC
AGC
A101
TUNER

R1704
3.9K

R720
10K

R729
150K

R1in
R524
5W47

N501
PC817B

R520
1W100K

R522
15K

C514
FK0.1
R519
15

R526
2.2K

L2in

XS801-2
AVout

R804
100K

R822
4.7K

R1703
4.7K

C729
0.01

R731
10K

R721
10K
V704
2SC1815
R730
10K R732
47K

L1in

V512
2SC3807
+

C819
220

C102
0.01

C708
50V4.7

R1702
8.2K

R724
4.7K

R734
10K

R733
X

C505
1000KM1000P

VD505
1N5408
VD506
1N5408

V1in
C515
FJ0.01

R531
1/2W5.6M

B6
12V

B7
5V
V821
2SC1815

R821
1K

R718
3W10K

N705
UPC574

C101
16V100

XS701

R1701
27K

R723
8.2K

R728
470

V702
VD703
2SA1015
HZ4A2

W704
X

W700
J
V703
2SC1815
V705
2SC1815

C503
1000KM1000P
VD503
1N5408
VD504
1N5408
C504
C506
1000KM1000P 1000KM1000P

C507
L502
250V470
HF2836
VD514
1N4148

VD517
EU1

VD516
1N4148
R517
100

R515
DJ22K

C533

+
C799
25V330
R713
1/2W270

+
C821
50V1

B7
5V

B1
130V

B5
5V

Rout

RT501
PTDCA1BF3R0Q100

R502
7WK1

R511
5.6K
V511
2SA1015

LIVE AREA

400KM2200S

R2in
VD553
1N4148

+ C302
35V1000

- 23 -

+
+

Lout

SW1701 SW1702 SW1703 SW1704 SW1705 SW1706

CH+
V+
VMENU AV/TV
CH-

R1700
150K

R722
1.5K

VD1701
TRL-R

XS501
1 TJC2-2A
2

00

C532
400KM470p
C502
250HM0.1

L501
HF2836
C501
250HM0.1

R501
1/2DJ220K

F501
233-3.15A/125V

RL551
OMIT-SS-112LM

SCL

CIRCUIT DIAGRAM OF TC24FS2H

Y
C
2

3
C572
10V470

JPP2197BCS32

R727
470

L909
QHXC-73Q

AC110V
60HZ

U902
NISPT-2

VD711
1N4002

V2in
V711
2SC1815

Lout
+

Vout

PARTS LIST FOR TC24FS2H

NO

DESCRIPTION

UNIT

QTY LOCATION

SPECIFICATION

E/RSAG7.820.031

PCS

A1 (THE MAIN PCB)

94V-0

1/6W CARBON RESISTOR

PCS

RT13-1/6W-2R2-J

PCS

R615 R625

1/6Watt

RT13-1/6W-75R-J

PCS

R803 W805

1/6Watt

RT13-1/6W-82R-J

PCS

R817 R818 R825

1/6Watt

RT13-1/6W-100R-J

PCS

R116 R241 R242 R766 R770 R774 R804 R834 R838

1/6Watt

RT13-1/6W-220R-J

PCS

R127 R744 R745 R833 R837

1/6Watt

RT13-1/6W-270R-J

PCS

R243

1/6Watt

RT13-1/6W-330R-J

PCS

R122 R612 R622 R725

1/6Watt

RT13-1/6W-470R-J

PCS

R727 R728

1/6Watt

10

RT13-1/6W-560R-J

PCS

R778 R780

1/6Watt

11

RT13-1/6W-680R-J

PCS

R409 R707 R611 R621

1/6Watt

12

RT13-1/6W-820R-J

PCS

R404

1/6Watt

13

RT13-1/6W-1K0-J

PCS

12

R103 R105 R119 R121 R201 R268 R458 R602 R819 R821

1/6Watt

14

RT13-1/6W-1K2-J

PCS

R202 R567

1/6Watt

15

RT13-1/6W-1K5-J

PCS

R722

1/6Watt

16

RT13-1/6W-1K8-J

PCS

R305

1/6Watt

R307 R401 R408 R760

1/6Watt

MAIN PCB
1

17

RT13-1/6W-2K2-J

PCS

18

RT13-1/6W-2K7-J

PCS

R244 R310

1/6Watt

19

RT13-1/6W-3K0-J

PCS

R272 R275 R454

1/6Watt

20

RT13-1/6W-3K3-J

PCS

R402 R742 R743 R820

1/6Watt

21

RT13-1/6W-3K9-J

PCS

R415

1/6Watt

22

RT13-1/6W-4K7-J

PCS

18

R274 R311 R724 R736 R738 R740 R747 R749 R751 R753 R809

1/6Watt

R811 R813 R814 R815 R816 R822 R827

1/6Watt

23

RT13-1/6W-5K6-J

PCS

R312

1/6Watt

24

RT13-1/6W-8K2-J

PCS

R301 R412 R723 R777 R779 R826

1/6Watt

25

RT13-1/6W-10K-J

PCS

25

R304 R414 R561 R566 R630 R631 R632 R708 R720 R721 R730

1/6Watt

R731 R733 R734 R735 R754 R772 R775 R819 R232 R413 R499

1/6Watt

R755 R761 R762

1/6Watt

26

RT13-1/6W-12K-J

PCS

R453 R455 R773 R776

1/6Watt

27

RT13-1/6W-22K-J

PCS

10

R205 R746 R748 R756 R757 R758 R759 R763 R764 R765

1/6Watt

28

RT13-1/6W-27K-J

PCS

R801 R824 R831 R835

1/6Watt

29

RT13-1/6W-33K-J

PCS

R101 R120

1/6Watt

30

RT13-1/6W-39K-J

PCS

R308 R309

1/6Watt

31

RT13-1/6W-47K-J

PCS

R206 R732

1/6Watt

32

RT13-1/6W-56K-J

PCS

R306

1/6Watt

33

RT13-1/6W-68K-J

PCS

R802 R805 R832 R836

1/6Watt

34

RT13-1/6W-100K-J

PCS

R102 R113 R114 R302

1/6Watt

35

RT13-1/6W-150K-J

PCS

R729

1/6Watt

36

RT13-1/6W-270K-J

PCS

R303 R726

1/6Watt

-24-

NO

DESCRIPTION

UNIT

QTY LOCATION

SPECIFICATION

37

RT13-1/6W-330K-J

PCS

R403

1/6Watt

38

RT13-1/6W-390K-J

PCS

R709

1/6Watt

39

RT13-1/6W-560K-J

PCS

R204

1/6Watt

40

RT13-1/6W-2M0-J

PCS

R207

1/6Watt

1/4W CARBON RESISTOR

41

RT14-1/4W-15R-J

PCS

R519

1/4Watt

42

RT14-1/4W-100R-J

PCS

R517

1/4Watt

43

RT14-1/4W-270R-J

PCS

R400

1/4Watt

44

RT14-1/4W-2K2-J

PCS

R526

1/4Watt

45

RT14-1/4W-3K3-J

PCS

R451

1/4Watt

46

RT14-1/4W-4K7-J

PCS

R553

1/4Watt

47

RT14-1/4W-5K6-J

PCS

R511

1/4Watt

48

RT14-1/4W-12K-J

PCS

R456

1/4Watt

49

RT14-1/4W-15K-J

PCS

R522

1/4Watt

50

RT14-1/4W-22K-J

PCS

R515 R556

1/4Watt

51

RT14-1/4W-39K-J

PCS

R457

1/4Watt

52

RT14-1/4W-220K-J

PCS

R446

1/4Watt

1/2W METAL OXIDE FILM RESISTOR

53

RY25-1/2W-1R-J

PCS

R452

1/2Watt

54

RY25-1/2W-120R-J

PCS

R461A

1/2Watt

55

RY25-1/2W-270R-J

PCS

R713

1/2Watt

56

RY25-1/2W-560R-J

PCS

R314

1/2Watt

57

RY25-1/2W-1K-J

PCS

R433

1/2Watt

58

RY25-1/2W-3K3-J

PCS

R557

1/2Watt

59

RY25-1/2W-47K-J

PCS

R555

1/2Watt

60

RY25-1/2W-100K-J

PCS

R552

1/2Watt

61

RY25-1/2W-150K-J

PCS

R554

1/2Watt

62

RY25-1/2W-220K-J

PCS

R501

1/2Watt

1W METAL OXIDE FILM RESISTOR

63

RY26-1W-1R0-J

PCS

R451A

1Watt

64

RY26-1W-100K-J

PCS

R520

1Watt

2W METAL OXIDE FILM RESISTOR

65

RY27-2W-4R7-J

PCS

R313

2Watt

66

RY27-2W-220R-J

PCS

R434

2Watt

67

RY27-2W-330R-J

PCS

R460

2Watt

68

RY27-2W-1K-J

PCS

R441

2Watt

69

RY27-2W-10K-J

PCS

R718

2Watt

70

RY27-2W-47K-J

PCS

R551

2Watt

3W METAL OXIDE FILM RESISTOR

71

RY28-3W-39R-J

PCS

R563

3Watt

72

RY18-3W-12K-J

PCS

R718

3Watt

PCS

W425

1/2Watt

1/2W INSURANCE RESISTOR

73

RF10-1/2W-3R3-J

-25-

NO

DESCRIPTION

UNIT

QTY LOCATION

SPECIFICATION

1W INSURANCE RESISTOR
74

RF10-1W-1R0-J

PCS

R472 R474

1Watt

75

RF10-1W-3R3-J

PCS

R491

1Watt

PCS

R562 R569

2Watt

PCS

R273

1/4Watt

PCS

R459

1Watt

2W INSURANCE RESISTOR
76

RF10-2W-1R0-J
1/4W METAL FILM RESISTOR

77

RJ14-1/4W-4K7-F
1W METAL FILM RESISTOR

78

RJ16-1W-1R-J
1/2W GLASS-GLAZED RESISTOR

79

RI40-1/2W-1K5-K

PCS

R233

1/2Watt

80

RI40-1/2W-5M6-K

PCS

R531 R532

1/2Watt

5W WIREWOUND RESISTOR
81

RX27-6-5W-47R-J1814

PCS

R524

5Watt

82

RX27-6-5W-6R8-J1814

PCS

R525

5Watt

PCS

R502

7Watt

7W WIREWOUND RESISTOR
83

RX27-3Y-7W-1R-J
VARIABLE RESISTOR

84

WI06-2-2-2K

PCS

RP551

0~2k

85

WI06-2-2-10K

PCS

RP302

0~10k

86

WI06-2-2-50K

PCS

RP301

0~50k

PCS

RT501

DEGAUSSING RESISTOR
87

PTDCA1BF3R0Q100

88

CERAMIC CAPACITOR

89

CC1-08A-CH-50V-15P-J

PCS

C704

50Voltage

90

CC1-08A-CH-50V-18P-K

PCS

C125 C705

50Voltage

91

CC1-06A-RH-50V-22P-J

PCS

C209

50Voltage

92

CC1-06A-RH-50V-39P-J

PCS

C126

50Voltage

93

CC1-10A-RH-50V-470P-J

PCS

C140 C771 C772

50Voltage

94

CT1-06A-2B4-50V-1000P-K

PCS

C123 C453 C315

50Voltage

95

CT1-08A-2F4-50V-0.01-Z

PCS

21

C102 C112 C116 C118 C119 C205 C245 C274 C279 C405 C607

50Voltage

C617 C627 C702 C703 C720 C729 C802 C804 C812 C999

50Voltage

96

CT1-08C-2B4-500V-10P-K

PCS

C455

500Voltage

97

CT1-08C-2B4-500V-1000P-K

PCS

C432

500Voltage

98

CT1-08C-2B4-500V-3900P-K

PCS

C433

500Voltage

99

CT81-08C-2R-1KV-470P-K

PCS

C554 C552

1000Voltage

100

CT81-06C-2R-1KV-1000P-K

PCS

C503 C504 C505 C506

1000Voltage

101

CT81-10C-B-1KV-2200P-K

PCS

C516

1000Voltage

102

CT81-10C-2R-2KV-470P-K

PCS

C551

2000Voltage

103

CT81-AC400V-E-470P-M

PCS

C532

400Voltage AC

104

CT81-AC400V-E-2200P-M

PCS

C533

400Voltage AC

PCS

C207 C515

63Voltage

POLYESTER CAPACITOR
105

CL11-63V-0.01-K

-26-

NO

DESCRIPTION

UNIT

QTY LOCATION

SPECIFICATION

106

CL11-63V-0.022-K

PCS

C120

63Voltage

107

CL11-63V-0.033-K

PCS

C406

63Voltage

108

CL21X-63V-0.22-K

PCS

C402

63Voltage

109

CL21X-63V-0.47-K

PCS

C403

63Voltage

110

CL21X-63V-0.1-K

PCS

C303 C304 C408 C514 C616 C626

63Voltage

111

CL21X-100V-0.1-K

PCS

C458 C459

100Voltage

112

CBB62-AC250V-0.1-M

PCS

(EMC)C501 (EMC)C502

250Voltage AC

POLYPROPYLENE CAPACITOR
113

CBB21A-400V-0.36-J

PCS

C441

400Voltage

114

CBB81A-2KV-9n1-J

PCS

C435 C438

2000Voltage

115

CBB13-630V-33n-J

PCS

C437

630Voltage

ELECTROLYTIC CAPACITOR
116

CD110-16V-2.2-M

PCS

C103 C618 C628 C714

16Voltage

117

CD110-16V-4.7-M

PCS

C203

16Voltage

118

CD110-16V-10-M

PCS

15

C276 C601 C602 C611 C621 C733 C734 C806 C807 C808

16Voltage

C809 C810 C811 C823 C825

16Voltage

119

CD110-16V-47-M

PCS

C206 C244 C404 C701 C719

16Voltage

120

CD110X-16V-100-M

PCS

C101 C115 C450 C612 C613 C622 C623 C631 C805

16Voltage

121

CD110X-16V-220-M

PCS

C801

16Voltage

122

CD110X-16V-470-M

PCS

C570 C572

16Voltage

123

CD110-25V-330-M

PCS

C799

25Voltage

124

CD110X-25V-470-M

PCS

C615 C625

25Voltage

125

CD110X-25V-2200-M

PCS

C457

25Voltage

126

CD110X-35V-47-M

PCS

C301 C411

35Voltage

127

CD110X-35V-100-M

PCS

C451 C472

35Voltage

128

CD110X-35V-1000-M

PCS

C302 C452

35Voltage

129

CD110-50V-0.47-M

PCS

C137 C139 C208 C401 C207A

50Voltage

130

CD110-50V-1-M

PCS

14

C117 C124 C136 C204 C212 C407 C412 C454 C456 C713

50Voltage

C803 C821 C822 C824

50Voltage

131

CD110-50V-4.7-M

PCS

C708

50Voltage

132

CD110-50V-10-M

PCS

C434

50Voltage

133

CD110-50V-470-M

PCS

C306 C567

50Voltage

134

CD110-50V-1000-M

PCS

C564 C565 C606

50Voltage

135

CD110-160V-1-M

PCS

C444

160Voltage

136

CD110-160V-33-M

PCS

C305

160Voltage

137

CD293-200V-220-M

PCS

C561

200Voltage

138

CD288-250V-22-M

PCS

C474

250Voltage

139

CD293-250V-470-M

PCS

C507

250Voltage

50Voltage

NO ELECTRODE ELECTROLYTIC CAPACITOR

140

CD71-50V-1-K

PCS

C231

INDUCTOR COIL
141

LGA0305-15H-K

PCS

L102 L121

142

LGA0305-39H-K

PCS

L701
-27-

NO

DESCRIPTION

UNIT

QTY LOCATION

143

TEM2011

PCS

L401

144

ZZ0008

PCS

(EMC)L431 (EMC)L432

145

TLN2854-540

PCS

L301

146

AC41

PCS

L441

SPECIFICATION

TRANSFORMER
147

JDT1904

PCS

T431

148

BCK-50-04

PCS

T511

149

BSC29-0142B

PCS

T471

FILTER
150

LCL-036

PCS

(EMC)L501

151

HF2836-562Y2R5-T01

PCS

(EMC)L502

PCS

15

VD401 VD402 VD514 VD516 VD552 VD553 VD610 VD611

DIODE
152

1N4148

VD612 VD620VD621 VD622 VD631 VD801 VD301

153

UZ3.6BSB

PCS

VD703

3.6Voltage

154

UZ6.2BSB

PCS

VD561

6.2Voltage

155

UZ8.2BSA

PCS

VD412

8.2Voltage

156

UZ5.6BSB

PCS

VD499

5.6Voltage

157

1Z75

PCS

VD452

158

EM01Z

PCS

VD451

159

RU4AM

PCS

VD551 VD554

160

EU2

PCS

VD472 VD555

161

1N5408

PCS

VD503 VD504 VD505 VD506

162

EU1

PCS

VD411 VD474 VD517

163

RU4DS

PCS

VD435

164

RU4C

PCS

VD436

165

ES1

PCS

VD556

PCS

15

V552 V553 V601 V632 V633 V703 V704 V705 V711V801

TRANSISTOR
166

2SC1815Y

V802 V803 V804 V821 V301

167

2SA1015Y

PCS

V302 V511 V631 V702

168

2SC3807

PCS

V512

169

2SB892S

PCS

V554

170

3DD3852

PCS

V303

171

2SC2383

PCS

V431

172

2SC4706

PCS

V513

173

3DD2553

PCS

V432

IC
174

LA76814

PCS

N101

Main IC

175

LC863232A-5V57

PCS

N701

CPU

176

LA7841

PCS

N451

Vertical Chip

177

LA4287

PCS

N601 N602

Sound Amplifier

178

L7805CV

PCS

N552 N553
-28-

NO

DESCRIPTION

UNIT

QTY LOCATION

SPECIFICATION

179

L7812CV

PCS

N551

180

CW574CS

PCS

N705

181

AT24C04

PCS

N702

E2PRROM

182

TC4053BP

PCS

N801

AV/TV SWITCH

PCS

N501

OPTICAL-ELECTRONIC COUPLER
183

PC817B/HS817
CERAMIC OSC

184

JA25D-3.58MHZ

PCS

(EMC)G201

3.58MHz

185

JA25D(32.768KHz)

PCS

(EMC)G701

32.768KHz

PCS

(EMC)Z101

PCS

F501

125Voltage 3.15Amp

PCS

RL551 RL552

10Amp 240V

PCS

(EMC)A101

SAW FILTER
186

D45U
FUSE

187

125V/250V-3.15A
RELAY

188

OMIT-SS-112LM
TUNER

189

TEDH9-243A
JUMPER

190

5mm

mm

W213 W701 W801 W818 W819 L511 C110 V102

191

7.5mm

mm

70

W102 W110 W118 W201 W203 W204 W205 W210 W215 W218 W221
W301 W302 W401 W402 W403 W405 W409 W410 W411 W416 W417
W419 W423 W424 W426 W451 W555 W562 W601 W605 W606 W607
W608 W609 W610 W616 W617 W620 W632 W700 W703 W704 W713
W716 W721 W722 W734 W735 W736 W740 W755 W756 W762 W803
W804 W805 W806 W807 W808 W809 W811 W812 W814 W815 W845
R270 R432 R781

192

10mm

mm

52

W109 W111 W113 W114 W117 W121 W123 W124 W125 W212 W214
W216 W222 W404 W407 W408 W412 W413 W414 W420 W421 W422
W431 W433 W473 W551 W557 W570 W612 W613 W626 W631 W702
W705 W706 W707 W708 W709 W710 W714 W718 W720 W723 W724
W725 W726 W727 W739 W750 W802 W813 W816

193

12.5mm

mm

10

W432 W442 W443 W474 W515 W602 W604 W624 W737 W761

194

15mm

mm

10

W472 W507 W553 W571 W623 W728 W729 W738 R442 R471

195

17.5mm

mm

W611

196

20mm

mm

W554 W799

PCS

13

L501-1 L501-2 L502-1 L502-2 T511-1 T511-7 T511-8 T511-14 T471-1

HOLLOW RIVET
197

XRY1.62.8BD

T471-2 T471-4 T471-8 T471-10

198

XRY2.53.5BD

PCS

22

C507+ C507- V513-1 V513-2 V513-3

POWER RADIATOR46 V432-1 V432-2 V432-3
H/V RADIATOR4567 RL551-1 RL551-2
-29-

NO

DESCRIPTION

UNIT

QTY LOCATION

SPECIFICATION

RL552-1 RL552-2 THE LEFT POWER MAGNIFY RADIATOR12

THE LEFT POWER MAGNIFY RADIATOR12
CONNECTOR
199

TJC7B-4Y-600

PCS

XS806

200

TJC7B-10Y-150

PCS

XS808

201

TJC7B-4Y-450

PCS

XS401

CONNECTOR PLUG
202

TJC7-2A

PCS

XS601 XS602 XS701 XS501A

203

TJC7-3A

PCS

A701

204

TJC7-5A

PCS

XS403

205

TJC2-2A

PCS

XS501

206

TJC2-3Y

PCS

XS502A

207

TJC2-5A

PCS

XS402

208

TJC3L-6A

PCS

XS603 XS604

HEAT SINK
209

RSR7.736.0102

PCS

210

RSR7.308.0181

PCS

211

RSAG5.861.0213

PCS

212

RSR5.861.0216

PCS

213

RSAG7.308.027

PCS

214

RSR7.308.0216

PCS

PCS

FOR FUSE

FUSE SUPPORTER
215

RSR7.736.0102

FRONT CONTROL PCB

216

E/RSAG7.820.152A

PCS

A2

94V-0

217

RT13-1/6W-1K5-J

PCS

R1707

1/6Watt

218

RT13-1/6W-2K7-J

PCS

R1706

1/6Watt

219

RT13-1/6W-3K9-J

PCS

R1705

1/6Watt

220

RT13-1/6W-4K7-J

PCS

R1704

1/6Watt

221

RT13-1/6W-8K2-J

PCS

R1703

1/6Watt

222

RT13-1/6W-27K-J

PCS

R1702

1/6Watt

223

RT13-1/6W-150K-J

PCS

R1701

1/6Watt

PCS

SW01 SW02 SW03 SW04 SW05 SW06

PCS

XS806

SWITCH
224

KAN-C202-5
CONNECTOR

225

TJC7-2Y-SCNW-1000

LATERAL AV PCB
226

E/RSAG7.820.153A

PCS

A3

94V-0

227

RT13-1/6W-82R-J

PCS

R1801 R1802

1/6Watt

228

RT13-1/6W-4K7-J

PCS

R1803 R1804

1/6Watt

229 AVZ1-8.4-1-1

PCS

XSS01

230 AVZ2-8.4-1A

PCS

XSS02

AV SOCKET

-30-

NO

DESCRIPTION

UNIT

QTY LOCATION

SPECIFICATION

PCS

XP1806

PCS

XS1807

PCS

A4

PCS

XS1801

235 TJC7L-10A

PCS

XS1802

236 TJC7L-4A

PCS

XS1803

237 E/RSAG7.820.035

PCS

A5

94V-0

238 RT13-1/6W-220R-J

PCS

R02 R03

1/6Watt

239 RT13-1/6W-2K2-J

PCS

R04

1/6Watt

240 RJ13-1/6W-160R-J

PCS

R05

1/6Watt

241 RJ13-1/6W-8K2-J

PCS

R06

1/6Watt

242 RT14-1/4W-56R-J

PCS

R01

1/4Watt

243 CD110-16V-100-M

PCS

C02 C14 C21

16Voltage

244 CD110-50V-1-M

PCS

C04 C11

50Voltage

245 CD110-50V-2.2-M

PCS

C06 C08

50Voltage

246 CD110-50V-4.7-M

PCS

C01 C05 C17 C19

50Voltage

247 CD110-50V-10-M

PCS

C03 C10 C12 C20 C22 C23 C24

50Voltage

248 CL21X-63V-0.015-K

PCS

C07

63Voltage

249 CL21X-63V-0.047-K

PCS

C18

63Voltage

250 CL21X-63V-0.1-K

PCS

C09 C13

63Voltage

251 CL21X-63V-0.22-K

PCS

C16

63Voltage

252 CL21X-63V-0.47-K

PCS

C15

63Voltage

PCS

X01

PCS

N01

PCS

XS01 XS02

256 E/RSAG7.820.036

PCS

A6

94V-0

257 RT13-1/6W-100R-J

PCS

R902 R912 R922

1/6Watt

258 RT13-1/6W-330R-J

PCS

R904 9914 R924

1/6Watt

259 RT13-1/6W-680R-J

PCS

R906 R916 R926

1/6Watt

260 RT13-1/6W-1K-J

PCS

R931

1/6Watt

261 RT13-1/6W-1K5-J

PCS

R933

1/6Watt

CONNECTOR
231 TJC7B-4Y-600
CONNECTOR PLUG
232 TJC7-4A

BACK AV PCB
233 E/RSAG7.820.034

94V-0

AV SOCKET
234 AV9S3-5
CONNECTOR PLUG

STEREO PCB

ELECTROLYTIC CAPACITOR

POLYESTER CAPACITOR

CERAMIC OSC
253 CSB503F58
IC
254 TDA9850

BTSC

PLUG
255 TJC3L-6P

VIDEO AMP PCB

- 31 -

NO

DESCRIPTION

UNIT

QTY LOCATION

SPECIFICATION

262 RT13-1/6W-10K-J

PCS

R900

1/6Watt

263 RT13-1/6W-15K-J

PCS

R932

1/6Watt

264 RT14-1/4W-33R-J

PCS

R935 R940

1/4Watt

265 RY25-1/2W-2K7-J

PCS

R908 R918 R928

1/2Watt

266 RY27-2W-15K-J

PCS

R907 R917 R927

2Watt

267 CC1-10A-50V-680P-J

PCS

C901 C911 C921

50Voltage

268 CC1-RH-50V-56P-J

PCS

C903 C913 C923

50Voltage

269 CT81-B-2KV-1000P-K

PCS

C939

2000Voltage

PCS

VD901 VD911 VD921 VD933

271 2SC1815Y

PCS

V932

272 2SA1015Y

PCS

V931

273 3DA4544

PCS

V902 V912 V922

PCS

XS901

PCS

XP902

276 TJC2-2A

PCS

XP903

277 TJC7-4A

PCS

XP901

278 E/RSAG7.820.178A

PCS

A7

94V-0

279 RT13-1/6W-470R-J

PCS

R1901

1/6Watt

PCS

VD1901

5Voltage

PCS

N1901

PCS

XP902

283 CABINET FRONT

PCS

284 REAR COVER

PCS

285 HOB

PCS

286 POWER BUTTON

PCS

287 SPRING

PCS

288 LENS LED

PCS

289 CUMMERBUND

PCS

CABINET FRONT

290 7X30mm

PCS

CABINET FRONT

291 7X50mm

PCS

CABINET FRONT

292 ORIENTED SUPPORTER

PCS

CABINET FRONT

CERAMIC CAPACITOR

DIODE
270 1N4148
TRANSISTOR

CRT SOCKET
274 GZS10-2 -AC2DG

94V-0

CONNECTOR
275 TJC7B-5Y-450
CONNECTOR PLUG

RECEIVE PCB

LED
280 BT-204L-31
IC
281 HS0038A2
CONNECTOR
282 TJC7B-3Y-250

ASSEMBLE LIST

CRT

3M ADHESIVE TAPE

-32-

NO

DESCRIPTION

UNIT

QTY LOCATION

293 ORIENTED BLOCK

PCS

CABINET FRONT

294 AV SUPPORTER

PCS

CABINET FRONT

295 SWITCH SUPPORTER

PCS

CABINET FRONT

296 KNOB

PCS

297 BUTTON

PCS

298 RSAG8.667.004

PCS

299 QH013

PCS

PCS

PCS

302 RSR8.942.0104

PCS

303 RSR8.610.0137

PCS

304 RSR8.683.0122

PCS

REAR COVER

305 RSR8.683.0116

PCS

REAR COVER

306 RSR8.683.0142

PCS

CABINET FRONT

307 E/RSR8.808.269

PCS

308 E/RSR8.808.092

PCS

309 E/RSR8.807.592

PCS

310 E/RSR8.808.086

PCS

PCS

312 BAR CODE

PCS

313 E/RSR8.817.002

PCS

314 E/RSR8.817.003

PCS

315 SJ2825-87 ST3X8C

PCS

AV BOARD

316 SJ2825-87 ST3X10C

PCS

LENS LED

317 SJ2825-87 ST3X12C

PCS

SWITCH SUPPORTER 2,RECIEVER 1

318 SJ2824-87 ST3X8C

PCS

BUTTON BOARD

319 SJ2824-87 ST4X12C

PCS

13

SPEAKER 8 ,BUTTON 2 ,AV BOARD 2,A1 BOARD 1

320 SJ2824-87 ST4X16C

PCS

AV BOARD 4 ,ORIENTED SUPPORTER 2

321 SJ2824-87 ST4X20C

PCS

28

CABINET FRONT,REAR COVER 8 AND HOB 20

PCS

CRT

323 MAIN PCB FRAME

PCS

324 AV BOARD

PCS

CABINET FRONT

CLIP

SPACER
300 RSR7.854.0108
RUBBER CUSHION
301 RSR8.683.0145
WASHER

SHOCKPROOF CLOTH

SCUTCHEON

LOGO
311 RSR8.809.0129
LABEL

SCREW

NUT
322 SJ2843-87 M6

FOLD LIST

-33-

SPECIFICATION

NO

DESCRIPTION

UNIT

QTY LOCATION

PCS

326 RSR8.667.0135

PCS

327 HOOK

PCS

328 SJ2825-87 ST3X12C

PCS

A1 BOARD

329 SJ2825-87 ST3X12C(BLACK)

PCS

AV BOARD

330 SJ2824-87 ST4X16C

PCS

FBT SUPPORTER

331 SJ2824-87 ST4X12C

PCS

FBT SUPPORTER 1,AV BOARD 2,CLIP 1

332 SJ2836-87 M3X8

PCS

SWITCH SUPPORTER

PCS

334 RSAG8.840.007

PCS

335 RSAG80840.005

PCS

336 E/RSR8.870.092

PCS

337 E/RSR8.870.093

PCS

PCS

12

339 24X400mm

PCS

340 72X2500mm

PCS

PCS

PCS

PCS

325 FBT SUPPORTER

CLIP

SCREW

PACKING LIST
PACKING BOX
333 E/RSR8.865.606
PACKING BAG

GASKET

STAPLE
338 Q/06.YGS01-90/TAPE

RC TRANSMITTER
341 HYDFSR-A202TY
BATTERY
342 LR6
USER MANUAL
343 IES030420

STRUCTURE LIST OF MAIN PCB

SCREW
344 SJ2832-87 ST3X8

PCS

345 SJ2835-87 ST3X12

PCS

346 SJ2835-87 ST3X8

PCS

PCS

348 GB97.1-85

PCS

349 RSR8.942.0106

PCS

350 RSR7.844.0113

PCS

PCS

NUT
347 GB6170-86 M3
WASHER

CLIP
351 RSR8.667.0132

-34-

SPECIFICATION

NO

DESCRIPTION

UNIT

QTY LOCATION

PCS

CRT
352 A59QDF891X002
POWER SWITCH
353 KDC-A04-0

PCS 1

DEGAUSSING WIRE
354 QHXC-3H

PCS

PCS

PCS

357 TJC2-5Y-500

PCS

XP402

358 TJC2-2Y-630

PCS

XS602

359 TJC2-2Y-500

PCS

XS601

360 TJC2-2Y-300

PCS

TO XS601

361 TJC2-2Y-B-1075

PCS

GROUND WIRE

SPEAKER
355 YDT613-10W8
POWER WIRE
356 NISPT-2
WIRING HARNESS

-35-

SPECIFICATION