346msds 0

MATERIAL SAFETY DATA SHEET
Total Solutions
P.O. Box 240014
Milwaukee, WI 53224
GENERAL INFORMATION NUMBER: (414) 354-6417 REVISION DATE: September 22, 2010
CHEMTREC: (800) 424-9300 DATE OF ISSUE: September 28, 2010
I - Product Identification
Rust Converter
PRODUCT CODE: 0346
CHEMICAL FORMULATION: Water based metal treatment.
NFPA HAZARD IDENTIFICATION SYSTEM: HEALTH: 1 FLAMMABILITY: 0 REACTIVITY: 0
HAZARD RATING: 4 - Extreme; 3 - High; 2 - Moderate; 1 - Slight; 0 - Insignificant
II - Hazardous Ingredients
Values reported as TWA unless noted.
APPROX OSHA ACGIH EPA 40 CFR:
SUBSTANCE % PEL TLV 302 355 372 CAS #
Tannic Acid 1.00-5.00 N/E N/E N N N 1401-55-4
2-Butoxyethanol 1.00-5.00 25 ppm (skin) 25 ppm (skin) N N Y 111-76-2
Oxalic Acid <1.0 1 mg/m3 1 mg/m3 N N N 144-62-7
Key: PEL: Permissible Exposure Limit TLV: Threshold Limit Value C: Ceiling level STEL: Short Term Exposure Limit
N/A: Not Applicable N/D: Not Determined N/E: Not Established Y: Yes N: No
302: CERCLA List of Hazardous Substances and Reportable Quantities (40 CFR 302.4).
355: SARA TITLE III / List of Extremely Hazardous Substances for Emergency Planning and Notification (40 CFR 355).
372: SARA TITLE III / List of Toxic Chemicals subject to Release Reporting (Community Right to Know) (40 CFR 372).
III - Physical Data
BOILING POINT (°F): N/D SPECIFIC GRAVITY: 1.13

VAPOR PRESSURE (mm Hg): N/D VOC CONTENT (% by weight): <3.0
VAPOR DENSITY (AIR = 1): N/D EVAPORATION RATE (WATER = 1): N/D
SOLUBILITY IN WATER: Soluble pH: 1.5-2.5
APPEARANCE AND ODOR: Beige, opaque emulsion: bland odor.
IV - Fire and Explosion Hazard Data
FLASH POINT (°F): N/A (TEST METHOD): Closed cup

FLAMMABLE LIMITS IN AIR (VOLUME %) UPPER: N/D LOWER: N/D
EXTINGUISHING MEDIA: Water, foam, carbon dioxide, dry chemical.
SPECIAL FIRE FIGHTING PROCEDURES: Cool drums in vicinity of fire with water fog. Fire fighters should be equipped with full
protective gear including self-contained breathing apparatus.
UNUSUAL FIRE AND EXPLOSION HAZARD: None
PRODUCT NAME: Rust Converter PRODUCT CODE: 0346
V - Reactivity Data
STABILITY: Stable
INCOMPATIBILITY: Oxidizers, strong alkalis.
CONDITIONS TO AVOID: None
HAZARDOUS DECOMPOSITION PRODUCTS: Thermal decomposition may produce oxides of carbon.
HAZARDOUS POLYMERIZATION: Will not occur.
VI - Health Hazard Data

ROUTES OF ENTRY INHALATION: X EYE CONTACT: X SKIN CONTACT: X INGESTION: X
INGREDIENTS THAT ARE CONSIDERED BY OSHA, NTP, IARC TO BE SUSPECTED HUMAN CARCINOGENS: None
EFFECTS OF OVEREXPOSURE
IF IN EYES: Moderate irritation and redness.
IF ON SKIN: Prolonged or repeated exposure can lead to mild irritation, formation of dark colored stains.
IF SWALLOWED: Gastrointestinal irritation, nausea, cramps, and vomiting. IF INHALED: May cause respiratory tract irritation,
headache, nausea.
EMERGENCY AND FIRST AID PROCEDURES
IF IN EYES: Flush eyes and under eyelids with plenty of cool water for at least 15 minutes. If irritation persists, obtain medical attention.
IF ON SKIN: Wash with soap and water. Remove contaminated clothing and launder separately before reuse. If irritation persists, obtain
medical attention.
IF SWALLOWED: Contact physician or poison center immediately. Never give anything by mouth to an unconscious person.
IF INHALED: Remove person to fresh air.
VII - Spill or Leak Protection

STEPS TO BE TAKEN IF MATERIAL IS RELEASED OR SPILLED: Ventilate area. Contain spill. Soak up spilled material with
inert absorbent material and place in properly labeled container for disposal.
WASTE DISPOSAL METHOD: Consult local environmental authorities.
VIII - Special Protection Information

RESPIRATORY PROTECTION: Use with adequate ventilation. If recommended Exposure Limits are exceeded wear a NIOSH
approved respirator, following manufacturer's recommendations.
VENTILATION LOCAL: Recommended MECHANICAL: Not required
PROTECTIVE GLOVES: Chemical resistant gloves.
EYE PROTECTION: Safety glasses or chemical goggles.
OTHER PROTECTIVE EQUIPMENT: Eye wash station.
PRECAUTIONS TO BE TAKEN IN HANDLING AND STORAGE: Store in a cool dry area. Do not freeze. Keep container tightly
closed when not in use.
OTHER PRECAUTIONS: Keep out of reach of children.
IX - Transportation Information (ground transportation only)

DOT ID NUMBER: None DOT PROPER SHIPPING NAME: None
DOT CLASS: None DOT PACKING GROUP: None
The shipping information listed above applies only to non-bulk (< 119 gallons) containers of this product. This product may have more than one proper shipping
name depending on packaging, product properties, & mode of shipment. If any alteration of packaging, product, or mode of transportation is further intended,
different shipping names and labeling may apply.
REVISED DATE: September 22, 2010 Prepared by: Technical Dept. DATE OF ISSUE: September 28, 2010
This information contained herein is based on data considered accurate. However, no warranty is expressed or implied regarding the accuracy of this data or the
results to be obtained from the use thereof. Total Solutions assumes no responsibility for personal injury or property damage to the vendee, users or third parties
caused by the material such vendees or users assume all risks associated with the use of this material.

346msds 0

Uploaded by

Copyright:

Available Formats

346msds 0

Uploaded by

Document Information

Original Title

Copyright

Available Formats

Share this document

Share or Embed Document

Sharing Options

Did you find this document useful?

Is this content inappropriate?

Copyright:

Available Formats

346msds 0

Uploaded by

Copyright:

Available Formats

MATERIAL SAFETY DATA SHEET

III - Physical Data

BOILING POINT (°F): N/D SPECIFIC GRAVITY: 1.13

IV - Fire and Explosion Hazard Data

FLASH POINT (°F): N/A (TEST METHOD): Closed cup

VI - Health Hazard Data

VII - Spill or Leak Protection

VIII - Special Protection Information

IX - Transportation Information (ground transportation only)

You might also like