MCM WIRING DIAGRAM ®

PIN PIN 1
91 LOOKING INTO VALVE COVER DDC RESPONSIBILITY
NO. DESCRIPTION NO. DESCRIPTION 3 93
1 2 3 4 5 6
REAR INLINE TO FRONT INLINE TO
1 Not Used 61 EGR Valve 5 95
SENSOR HARNESS SENSOR HARNESS
2 Not Used 62 Power Supply 7 12 11 10 9 8 7
3 Not Used
97 JAKE REAR JAKE FRONT
63 Not Used 9 R = REAR
4 Spill Control Valve (cyl 4)-pin 4 64 Power Supply 99 F = FRONT
FRONT
5 Spill Control Valve Common-pin 3 65 Electronic Dosing Valve 11
101 CONNECTOR = GREY F7(66) F8(91) F12(32) F11(62)
6 Spill Control Valve (cyl 6)-pin 4 66 Jake Rear
7 13
Spill Control Valve Common-pin 3 67 Ground 103
8 Spill Control Valve (cyl 5)-pin 4 68 Not Used 15
105 1 2 3 4 5 6 R9(21) 1 R5(19) 1 R3(17) 1 F10(23, 25, 27) 1 F10(23, 25, 27) 1 F10(23, 25, 27) 1
9 Spill Control Valve Common-pin 3 69 Fuel Cutoff Valve
10 Spill Control Valve (cyl 2)-pin 4 70 Ether Start R10(18) R6(20) R2(16) F5(24) F3(22) F1(26)
18 2 INJ 2 INJ 2 2 2 2
11 Spill Control Valve Common-pin 3 12 11 10 9 8 7 INJ INJ INJ INJ
71 Not Used 108 R11(9) 6 R7(7) 5 R4(5) 4 F9(11, 13, 15) 3 F9(11, 13, 15) 2 F9(11, 13, 15) 1
12 Spill Control Valve (cyl 3)-pin 4 20 3 3 3 3 3 3
72 Not Used
13 Spill Control Valve Common-pin 3 110 R12(6) R8(8) R1(4) F6(12) F4(10) F2(14)
73 Not Used 22 REAR 4 4 4 4 4 4
14 Spill Control Valve (cyl 1)-pin 4 74 VNT CAN (-) 112 CONNECTOR = BLACK
15 Spill Control Valve Common-pin 3
16 Needle Control Valve (cyl 4)-pin 2
75
76
VNT CAN (+)
Not Used INJECTOR HARNESS (WITH JAKE BRAKE)
17 Needle Control Valve Common-pin 1 77 Supply Fuel Temperature Sensor
18 Needle Control Valve (cyl 6)-pin 2 78 Not Used 30 LEFT SENSOR HARNESS
19 Needle Control Valve Common-pin 1 79 Not Used
20 Needle Control Valve (cyl 5)-pin 2 120 PIN NO CAVITY LABEL
80 Not Used PIN NO
PIN NO
21 Needle Control Valve Common-pin 1 81 Not Used 60 55 42
90 1 SUPPLY 1
22 Needle Control Valve (cyl 2)-pin 2 82 Sensor Power Supply FUEL TEMPERATURE TRS (CKP) PLUG
23 Needle Control Valve Common-pin 1 83 EGR Temperature Sensor
120-PIN 77 2 43 1
SENSOR 2
24 Needle Control Valve (cyl 3)-pin 2 84 Fuel Compensation Pressure Sensor CONNECTOR PLUG
2
25 Needle Control Valve Common-pin 1 85 Sensor Power Supply PLUG
26 Needle Control Valve (cyl 1)-pin 2 44 3
86 Turbo Compressor InTemp Sensor PIN NO 52 1 INTAKE AIR 1
27 Needle Control Valve Common-pin 1 87 Intake Manifold Pressure Sensor TEMPERATURE
102 1 INTAKE MANIFOLD SRS (CMP)
PLUG
4
65 87 45
28 Not Used 88 Sensor Ground 1 ELECTRONIC 106 2 SENSOR 2 PRESSURE 2
PLUG
DOSING 58 5
29 DOC Outlet Temp Sensor 89 DOC Inlet Temp Sensor 64
3 SENSOR
2 VALVE
30 DPF Outlet Pressure Sensor 90 Sensor Position PLUG
6
TURBO
31 Not Used Intake Air Throttle Valve 52 88
1
1 EGR COMPRESSOR PLUG
32 Jake Front 91 Power Supply 69 TEMPERATURE
117 1 EGR IN TEMPERATURE
7
1 FUEL 86
33 Two-speed Fan or Variable-speed Fan 92 Not Used 83 2 SENSOR
103 2 DELTA PRESSURE
2
SENSOR 70 ETHER START
CUTOFF 109 8
34 Not Used 93 Power Supply 64 2 3 SENSOR (OEM INSTALLED)
35 VALVE 33 FAN CONTROL #2
Not Used 94 Not Used 9
36 Not Used 61
95 Not Used 1
EGR 98 FAN CONTROL #1
10
37 62
Not Used 96 Not Used 111 1 2
VALVE
38 Ground 67 PLUG
97 Not Used 3 CONTROL 11
39 Not Used 82 FUEL LINE 60
98 Single-Speed Fan or Two-Speed Fan 2 4 PLUG
40 Not Used PRESSURE 12
99 Not Used PLUG SENSOR
41 Not Used 100 Intake Air Throttle (+)
3 PLUG
13
42 CKP/TRS(-) 101 Intake Air Throttle (-) 104 90 1 PIN NO PIN NO PIN NO PLUG
4
43 CKP/TRS(+) 102 14
Sensor Ground 103
44 CMP/SRS(-) 103 Sensor Ground 2
INTAKE
4
1
26
1
55
1
PLUG
15
45 CMP/SRS(+) 104 Sensor Ground 84 1 117 AIR
3 16 14 110 PLUG
46 Not Used 105 Sensor Ground FUEL THROTTLE 2 2 2 16
82
47 Fan Speed 106 Intake Air Temperature Sensor 2
COMPENSATION
100
4 VALVE 17 22 108 29 DOC OUTLET TEMP SENSOR
3 3 3 17
48 Not Used 107 Not Used PLUG PRESSURE
49 Not Used 3 101 5 89 DOC INLET TEMP SENSOR
108 Engine Oil Temperature Sensor SENSOR 5 10 74 18
4 4 4
50 Sensor Ground 109 EGR Delta Pressure Sensor 104 4 115 DPF OUTLET TEMP SENSOR
51 19
Turbo Speed Sensor 110 Engine Coolant Temperature Sensor 19
5
24
5
75
5
INLINE INLINE CONNECTS PLUG
52 Sensor Ground 111 Fuel Line Pressure Sensor TO TO TO RIGHT 20
53 Not Used 20 12 93 SENSOR
112 Turbo Compressor Out Temp Sensor 6 INJECTOR 6 INJECTOR 6
HARNESS PLUG
54 Engine Oil Pressure Sensor REAR FRONT 21
113 Not Used RIGHT SENSOR HARNESS 7 66 38
55 Sensor Ground 114 Sensor Ground 7 7 7 91 POWER SUPPLY
22
56 Not Used 115 DPF Outlet Temp Sensor PIN NO 8 91 FAN SPEED
105 47 23
57 Not Used 116 Not Used 50
55 1 ENGINE
8 8 8
58 Sensor Power Supply 1 TURBO 88 SENSOR GND
117 Sensor Power Supply 51
2 SPEED 110
COOLANT TEMP 21
9
11, 13, 15
9
50
9 24
59 Not Used 118 DPF Inlet Pressure Sensor 2 SENSOR
SENSOR PLUG
60 EGR Valve Position 119 Not Used 18 10
23 25, 27
10 51 25
10
120 Not Used PLUG
55
26
93 1 ENGINE OIL 9 62 52
1 11 11 11 TCI TEMP SENSOR
86 27
38 TURBO TEMPERATURE
2 108 6 32 112
ACTUATOR 2 SENSOR SENSOR RETURN
74 3 12 12 12 114 28
75 (CAN)
4 54 85 SENSOR SUPPLY
13 DPF OUTLET 29
52 TURBO
1 30 PRESSURE SENSOR
COMPRESSOR 82 30
14 DPF INLET
112 2 OUT TEMPERATURE 118 PRESSURE SENSOR
SENSOR 31

105
54
1 ENGINE OIL DDEC VI SERIES 60 MCM
EGR ENGINE HARNESS
Specifications are subject to change without notice. Detroit Diesel Corporation is registered to ISO 9001:2001. 2 PRESSURE
82 3
Copyright © Detroit Diesel Corporation. All rights reserved. Detroit Diesel Corporation is a Daimler company. SENSOR
47852_PSL
DDC-SVC-MAN-0054 0806 Copyright © 2008 DETROIT DIESEL CORPORATION. Printed in U.S.A.
18-PIN CONNECTOR #1
1 2 3
1/1 TWO-SPEED AXLE
1/2 PARK BRAKE INTERLOCK 4 5 6
1/3 IDLE VALIDATION SWITCH 2 (THROTTLE ACTIVE)
7 8 9 GOVERNOR CRUISE CONTROL
1/4 THROTTLE POSITION SENSOR GND
1/5 DPF REGENERATION LAMP 10 11 12 CAVITY DASH PANEL ENGINE COOLANT LEVEL SENSOR - SHUTDOWN
THROTTLE PEDAL
1/6 IDLE VALIDATION SWITCH 1 (IDLE ACTIVE) 13
CRUISE CAVITY LABEL
14 15 CAVITY LABEL ENABLE
1/7 THROTTLE POSITION SENSOR 1/14 SWITCH OFF
COOLANT
ON 3/11 COOLANT LEVEL
1/8 THROTTLE POSITION SENSOR SUPPLY 16 17 18 1/7 ALSG A AUTOMOTIVE A LEVEL
1/9 TACHOMETER 1/4 SENSOR GND LIMITING 1/16
RESUME/ACCEL
SWITCH
ON
3/2 SENSOR RETURN SENSOR
B OFF B
1/10 STOP ENGINE / AUX SHUTDOWN #1 WHITE - FRONT SPEED SHUTDOWN
LOOKING INTO PINS 1/8 SENSOR SUPPLY C
1/11 LIMITER 0 / LIMITING TORQUE CURVE ON THE HARNESS
GOVERNOR
1/12
SET/COAST
SWITCH
OFF
1/12 SET / COAST ENABLE ON
1/13 MIL LAMP SERVICE BRAKE
1/3 IVS #2 2/7 SWITCH
1/14 CRUISE CONTROL ENABLE D IDLE ON
1/15 STOP ENGINE OVERRIDE / DIAGNOSTIC REQUEST 1/6 IVS #1 E VALIDATION CLUTCH OFF
1/16 RESUME / ACCEL ENABLE 2/2 (REQUIRED) 4/8 SWITCH 2/2 - GND DIAGNOSTIC CONNECTOR - REQUIRED
GROUND F ON
1/17 SPARE OFF
CAVITY DDC CONNECTOR LABEL
1/18 RUN START VEHICLE SPEED SENSOR
1 2 3
- A GND
18-PIN CONNECTOR #2 4 5 6
3/3 SENSOR SUPPLY C
3/13 SIGNAL
- B +12 V
2/1 MAIN BATTERY (+12V) 3/4 PTO B PTO 3/14
2/18 C J1939 DATA LINK (+)
7 8 9
2/2 MAIN BATTERY GROUND 3/2 SENSOR RETURN (OPTIONAL) RETURN
2/16 D J1939DATA LINK (-)
A
2/3 IGNITION 10 11 12 2/17 E J1939 SHIELD
2/4 K-LINE TOP 2 TRANSMISSION 2/5 F J1587 DATA LINK (+)
2/5 J1587+ 13 14 15
TOP 2 LOCKOUT 2/6 G J1587 DATA LINK (-)
2/9 REMOTE PTO SWITCH SOLENOID
2/6 J1587- 16 17 18 3/7
- H PLUG
REMOTE THROTTLE 2/2 - GND
2/7 SERVICE BRAKE RELEASED SWITCH 2/8 SELECT SWITCH - J PLUG
2/8 REMOTE THROTTLE SELECT SWITCH TOP 2 SHIFT
GRAY - FRONT SOLENOID 2/2 - GND
2/9 REMOTE PTO SWITCH LOOKING INTO PINS 3/8
ON THE HARNESS
2/10 AMBER WARNING LAMP 21 20 19
2/11 LIM 1 / FAST IDLE / ALT ROAD SPEED LIMIT / ALT ETC 18 17 16
2/12 A/C STATUS CONNECTS TO ENGINE HARNESS INSTRUMENT PANEL
2/13 FAN OVERRIDE 31-PIN CONNECTOR OEM-MCM 21-PIN CONNECTOR 15 14 13
ENGINE 12 11 10 CAVITY LABEL
2/14 ENGINE BRAKE LOW CAVITY LABEL SERIES CAVITY LABEL HIGH EXHAUST SYSTEM
9 8 7 TEMP LAMP
2/15 ENGINE BRAKE MEDIUM
2/16 J1939- 1 SPARE M21/1 NOT USED 6 5 4
4/7 HEST
POWER SUPPLY - 3 2 1
IGN
2/17 J1939 SHIELD 2 IGN HDE I5A
M21/2 NOT USED
2/18 J1939+ +12V MALFUNCTION
30A INDICATOR LAMP
3 FUEL HEATER SUPPLY (+) #1 MBE 900, HDE
+12V
M21/3 NOT USED
21-PIN CONNECTOR #3 FRONT 1/13 MIL
IGN
4 SPARE M21/4 NOT USED LOOKING INTO PINS
3/1 OI THERMOSTAT 1 2 3 ON THE HARNESS
3/2 SENSOR RETURN 4 5 6
5 FUEL HEATER SUPPLY #2 MBE 900, HDE M21/5 BATTERY GND RED STOP LAMP
3/3 SENSOR SUPPLY 6 M21/6
7 8 9 SPARE 3/16 RSL
3/4 REMOTE PTO 20
21
22 10AMP IGN
3/5 SPARE 7 POWER SUPPLY - GND HDE 9 M21/7
10 11 12
19
8 23 IGN
10
3/6 SPARE 31
7
2
11
AMBER WARNING LAMP
13 14 15 8 ETHER START S60 18 3 M21/8
3/7 TOP 2 LOCKOUT SOLENOID VARIABLE SPEED FAN CONTROL 30
6
1 24
2/10 AWL
12
3/8 TOP 2 SHIFT SOLENOID 16 17 18 9 OR HIGH OF 2-SPEED FAN ALL 17
5
4 M21/9 IGN
25
16 13
3/9 AGS 2 BACKUP LAMP 19 20
SINGLE SPEED FAN CONTROL 29 14
21 10 OR LOW OF 2-SPEED FAN ALL 15 M21/10 ENGINE CAN SHIELD CPC 4/2
3/10 AGS 2 TRANS TEMP LAMP 28
27
26 DPF REGENERATION LAMP
3/11 LOW COOLANT LEVEL SENSOR 11 M21/11 40AMP
BROWN FUEL HEATER GROUND #1 MBE 900, HDE
BATTERY (+) 1/5 DPF
3/12 AGS 2 CHECK TRANS LAMP IGN
FRONT 12 SPARE M21/12
3/13 VEHICLE SPEED (+) LOOKING INTO PINS
3/14 VEHICLE SPEED (-) ON THE HARNESS FRONT 1/9 TACH OUTPUT
13 SPARE
LOOKING INTO PINS M21/13 ENGINE CAN (+) CPC 4/3
3/15 AMBIENT AIR TEMPERATURE SENSOR
ON THE HARNESS
3/16 RED STOP LAMP 14 WATER-IN-FUEL SENSOR SUPPLY MBE 900 M21/14
3/17 OI ALARM SWITCHES
15 WATER-IN-FUEL SENSOR GROUND MBE 900 M21/15
3/18 ABS ACTIVE (AGS 2 TRANS) ENGINE BRAKE 2/14 ENG. BRAKE LOW
3/19 NOT USED 16 SOLENOID CONTROL MBE 900 M21/16 NOT USED
3/20 NOT USED DOC OUTLET 2/2 - GND
17 2/15 ENG. BRAKE MED
TEMPERATURE SENSOR ALL M21/17 NOT USED
3/21 NOT USED DOC INLET
18 TEMPERATURE SENSOR ALL M21/18 NOT USED SEO SWITCH
18-PIN CONNECTOR #4 DPF OUTLET ENGINE SHUTDOWN
1 2 3 19 M21/19
TEMPERATURE SENSOR ALL ENGINE CAN (-) CPC 4/1 1/15 OVERRIDE
4/1 ENGINE CAN (-) 2/2 - GND
4 5 6
4/2 ENGINE CAN SHIELD 20 FUEL HEATER GROUND #2 MBE 900, HDE M21/20 RUN/START CPC 1/18
4/3 ENGINE CAN (+) 7 8 9 5 (29) 2/12 A/C STATUS
21 SPARE M21/21 STARTER STARTER
4/4 SPARE POWER SUPPLY - ENG. BRAKE,
10 11 12 6 (89) RELAY 2/2 - GND
4/5 SPARE 22 FAN, ETHER ALL TO 2/13 FAN CTRL OVERRIDE
4/6 WAIT TO START LAMP (GRID HEATER) 13 14 15 10-PIN DPF MCM ENGINE START ONLY
23 FAN SPEED ALL 7 (115) CONNECTOR
4/7 HIGH EXHAUST SYSTEM TEMP LAMP 16 17 18 1/2 PARK BRAKE
4/8 CLUTCH RELEASED 24 SENSOR GROUND ALL 8 (88) CONNECTOR CPC POWER WIRING 2/2 - GND
4/9 OI ACTIVE LAMP P/N: 54201016
BLUE 25 SPARE 1 (114) CAVITY LABEL VEHICLE POWER
4/10 VEHICLE POWER SHUTDOWN 4/10 SHUTDOWN
FRONT TERMINAL 2/2 - GND
4/11 SPARE LOOKING INTO PINS 26 WATER-IN-FUEL SENSOR MBE 900 2 (85) P/N: LSP-1811-58AU
4/12 VEHICLE SPEED OUTPUT ON THE HARNESS 2/1 CPC BATTERY (+) REGEN
4/13 SPARE 27 TCI TEMP. S60 4 (30) PLUG: 4/17 SWITCH 2/2 - GND
P/N: 54200005 2/2 CPC GROUND
4/14 SPARE 28 SENSOR GROUND ALL 3 (118) 2/3 CPC IGNITION
4/15 SPARE

DDEC VI (CPC)
4/16 NEUTRAL SWITCH 29 SENSOR SUPPLY ALL PLUG 9
4/17 REGEN SWITCH DPF OUTLET
30 PRESSURE SENSOR ALL PLUG 10
4/18 HOOD TILT SWITCH

VEHICLE INTERFACE HARNESS

DPF INLET
All information subject to change without notice. (Rev. 1/07) 31 PRESSURE SENSOR ALL
7SA827 0701 Copyright © 2007 DETROIT DIESEL
45733