https://www.phoenixcontact.

com/us/products/1774687

Connector - PV-CM-S 2,5-6 (-) - 1774687

Please be informed that the data shown in this PDF Document is generated from our Online Catalog. Please find the complete data in the user's
documentation. Our General Terms of Use for Downloads are valid
(http://phoenixcontact.com/download)

Photovoltaic connector, Range of articles: Sunclix, Connector, housing material: PPE, color: black, number of
positions: 1, min. conductor cross section: 2.5 mm², max. conductor cross section: 6 mm², rated current: 27 A,
Connection method: Spring-cage, Type of contact: Pin

Key Commercial Data

Packing unit 1 pc
Minimum order quantity 50 pc

GTIN

GTIN 4046356480192
Weight per Piece (excluding packing) 13.600 g
Custom tariff number 85359000
Country of origin Germany

Technical data
Dimensions
External cable diameter 5.5 mm ... 8 mm

Ambient conditions
Degree of protection (when plugged in) IP66 / IP68 (2 m / 24 h)
Ambient temperature (operation) -40 °C ... 85 °C
Ambient temperature (assembly) -25 °C ... 50 °C

General
Design Pin
Tightening torque nut 2 Nm ±0.1 Nm
Insertion force 45 N ±10 N

07/20/2021 Page 1 / 6
https://www.phoenixcontact.com/us/products/1774687

Connector - PV-CM-S 2,5-6 (-) - 1774687

Technical data
General
Disconnect force 250 N ±50 N (when locked)
Pull-out force of cable >= disconnect force > 330 N
Insertion/withdrawal cycles 100
Degree of pollution 3
Rated current 27 A
35 A
Degree of protection IP66 / IP68 (2 m / 24 h)
Number of positions 1
Current 35 A
Rated surge voltage (III/3) 12.8 kV
pluggable Yes
Degree of protection IP66 / IP68 (2 m / 24 h)
Overvoltage category III
Rated voltage 1100 V
Rated current (2.5 mm²) 27 A
Rated current (4.0 mm²) 35 A
Rated current (6.0 mm²) 40 A
Nominal cross section 6 mm²
Protection class II

Material
Color black
Insulating material mPPE
Contact material Cu
Contact surface material Ag

Connection data
Connection method Spring-cage
Connection capacity 2.5 mm² ... 6 mm²
Contact resistance with connected conductor 0.45 mΩ
Stripping length 15 mm
Cable type H1Z2Z2-K lines
Type of contact Pin
Current 27 A
35 A

Standards and Regulations

Flammability rating according to UL 94 V0

07/20/2021 Page 2 / 6
https://www.phoenixcontact.com/us/products/1774687

Connector - PV-CM-S 2,5-6 (-) - 1774687

Technical data
Standards and Regulations
• WARNING: Commission properly functioning products only. The products
Safety note must be regularly inspected for damage. Decommission defective products
immediately. Replace damaged products. Repairs are not possible.
• WARNING: Only electrically qualified personnel may install and operate
the product. They must observe the following safety notes. The qualified
personnel must be familiar with the basics of electrical engineering. They
must be able to recognize and prevent danger. The relevant symbol on the
packaging indicates that only personnel familiar with electrical engineering
are allowed to install and operate the product.
WARNING: The connectors may not be plugged in or disconnected under
load. Ignoring the warning or improper use may damage persons and/or
property.
• The products are suitable for applications in plant, controller, and
electrical device engineering.
• Assembled products may not be manipulated or improperly opened.
• Only use mating connectors that are specified in the technical data of the
standards listed (e.g. the ones listed in the product accessories online at
phoenixcontact.com/products).
• When using the product in direct connection with third-party
manufacturers, the user is responsible.
• For operating voltages > 50 V AC, conductive connector housings must
be grounded
• Ensure that the protective or functional ground has been properly
connected.
• Observe the corresponding technical data. You will find information:
o On the product
o On the packing label
o In the supplied documentation
o Online at phoenixcontact.com/products under the product
• The installation notes/Design In documents online on the download page
at phoenixcontact.com/products must be observed for this product.
• Use a protective cap to protect connectors that are not in use. The
suitable accessories are available online in the accessory section of the
product at phoenixcontact.com/products
• The connector warms up in normal operation. Depending on the ambient
conditions, the surface of the connector can continue to warm up. In
this case, the user is responsible for posting warnings (e.g. DIN EN ISO
13732-1:2008-12).
• Operate the connector only when it is fully plugged in and interlocked.
• Ensure that when laying the cable, the tensile load on the connectors
does not exceed the upper limit specified in the standards.
• Observe the minimum bending radius of the cable. Lay the cable without
twisting it.

Environmental Product Compliance

China RoHS Environmentally friendly use period: unlimited = EFUP-e

07/20/2021 Page 3 / 6
https://www.phoenixcontact.com/us/products/1774687

Connector - PV-CM-S 2,5-6 (-) - 1774687

Technical data
Environmental Product Compliance
No hazardous substances above threshold values

Drawings

Dimensional drawing

Ø18,6 58,3
26,4

15 16

Classifications
eCl@ss

eCl@ss 10.0.1 27440109

eCl@ss 11.0 27440109
eCl@ss 4.0 27260700
eCl@ss 4.1 27260700
eCl@ss 5.0 27260700
eCl@ss 5.1 27260700
eCl@ss 6.0 27260700
eCl@ss 7.0 27440102
eCl@ss 9.0 27440103

ETIM

ETIM 3.0 EC001121

ETIM 4.0 EC001753
ETIM 6.0 EC002061

UNSPSC

UNSPSC 6.01 30211810

UNSPSC 7.0901 39121409
UNSPSC 11 39121409
UNSPSC 12.01 39121409
UNSPSC 13.2 39121413
UNSPSC 18.0 39121413
UNSPSC 19.0 39121413
07/20/2021 Page 4 / 6
https://www.phoenixcontact.com/us/products/1774687

Connector - PV-CM-S 2,5-6 (-) - 1774687

Classifications
UNSPSC
UNSPSC 20.0 39121413
UNSPSC 21.0 39121413

Accessories
Accessories
Photovoltaic connector

Protective cap - PV-C PROTECTION CAP - 1785430

Photovoltaic connector, Range of articles: Sunclix, Protective cap, color: black. self-sealing, without interlock, set
consisting of: 1 protective cap for connector side and 1 protective cap for coupling side

Filler plugs - PV-C PLUG - 1775631

Photovoltaic connector, Range of articles: Sunclix, Filler plugs, color: black

Screwdriver tools

Screwdriver - SZF 1-0,6X3,5 - 1204517

Actuation tool, for ST terminal blocks, also suitable for use as a bladed screwdriver, size: 0.6 x 3.5 x 100 mm, 2-
component grip, with non-slip grip

Stripping tool

Stripping pliers - QUICK WIREFOX 6 SC - 1207637

Stripping tool for short-circuit proof conductors, stripping range: 1.5 up to 6 mm², wire cutting up to 6 mm² cable stopper
up to 18 mm²

07/20/2021 Page 5 / 6
https://www.phoenixcontact.com/us/products/1774687

Connector - PV-CM-S 2,5-6 (-) - 1774687

Accessories

Stripping tool - WIREFOX-D SR 6-1 - 1212511

Stripping tool, for standard 2.5, 4, and 6 mm² solar cables, with 15 mm length stop, for SUNCLIX field connectors

Phoenix Contact 2021 © - all rights reserved

http://www.phoenixcontact.com

07/20/2021 Page 6 / 6