CONTROL MODULE PIN-OUT INFORMATION Fig. 14.

1
General Electronic Module

Pin Description and Characteristic COMPONENTS
I CA86-16 SET SWITCH: OPEN CIRCUIT / GROUND Component Connector(s) Connector Description Location
DOOR LATCH – DRIVER DD3 8-WAY / BLACK DRIVER DOOR
O CA87-17 GLOBAL CLOSE REQUEST: 20 mS PULSED SIGNAL
DD9 2-WAY / BLACK
DOOR SWITCH PACK – DRIVER DD1 20-WAY / BLACK DRIVER DOOR CASING
I IP5-03 SEDAN (EXCEPT JAPAN AND S. KOREA): EXTERNAL ANTENNA
DOOR SWITCH PACK – LH REAR BL1 8-WAY / BLACK LH REAR DOOR CASING
I IP5-23 REMOTE RF SIGNAL
DOOR SWITCH PACK – PASSENGER PD10 8-WAY / BLACK PASSENGER DOOR CASING
DOOR SWITCH PACK – RH REAR BR1 8-WAY / BLACK RH REAR DOOR CASING
SG IP6-01 LOGIC GROUND: GROUND
GENERAL ELECTRONIC MODULE CA86 23-WAY / GREY BEHIND INSTRUMENT PANEL / RH SIDE
CA87 23-WAY / GREEN
B+ JB172-01 BATTERY POWER SUPPLY (LOCKING): B+
IP5 23-WAY / BROWN
IP6 23-WAY / NATURAL
JB172 23-WAY / BLUE
NOTE: Refer to the Appendix at the rear of this book for Network Messages.
RF MODULE RC35 3-WAY / BLACK ROOF CONSOLE
WINDOW MOTOR – DRIVER DD2 8-WAY / GREY DRIVER DOOR
WINDOW MOTOR – LH REAR BL2 8-WAY / GREY LH REAR DOOR
WINDOW MOTOR – PASSENGER PD2 8-WAY / GREY PASSENGER DOOR
WINDOW MOTOR – RH REAR BR2 8-WAY / GREY RH REAR DOOR

HARNESS IN-LINE CONNECTORS

Connector Connector Description Location
CA15 20-WAY / BLACK / CABIN HARNESS TO DRIVER DOOR HARNESS DRIVER DOOR / DOOR CASING
CA16 20-WAY / BLACK / CABIN HARNESS TO DRIVER DOOR HARNESS DRIVER DOOR / DOOR CASING
CA20 20-WAY / BLACK / CABIN HARNESS TO PASSENGER DOOR HARNESS PASSENGER DOOR / DOOR CASING
CA25 14-WAY / NATURAL / CABIN HARNESS TO LH REAR DOOR HARNESS LH ‘B/C’ POST / ‘B/C’ POST TRIM
CA30 14-WAY / NATURAL / CABIN HARNESS TO RH REAR DOOR HARNESS RH ‘B/C’ POST / ‘B/C’ POST TRIM
CA36 16-WAY / GREEN / CABIN HARNESS TO ROOF HARNESS LH ‘A’ POST / WINDSHIELD PILLAR
CA40 16-WAY / GREY / CABIN HARNESS TO ROOF HARNESS RH ‘A’ POST / WINDSHIELD PILLAR
CA240 12-WAY / GREY / CABIN HARNESS TO INSTRUMENT PANEL HARNESS LH LOWER ‘A’ POST / ‘A’ POST TRIM

GROUNDS
Ground Harness Location
G4 CA LOWER RH ‘A’ POST
G5 IP UPPER RH ‘A’ POST
G15 CA LOWER LH ‘A’ POST

FOR CONTROL MODULE PIN-OUT INFORMATION, UNFOLD PAGE TO LEFT.

The following abbreviations are used to represent values for Control Module Pin-Out data

I Input PG Power Ground C CAN Network D Serial and Encoded Data

O Output SS Sensor / Signal Supply V S SCP Network V Voltage (DC)
B+ Battery Voltage SG Sensor / Signal Ground D2 D2B Network PWM Pulse Width Modulated

CAUTION: The information on this data page is furnished to aid the user in understanding circuit oper ation. THIS INFORMATION SHOULD BE USED FOR
REFERENCE ONLY.

NOTE: The values listed are approximately those that can be expected at the control module connector pins with all circuit connections made and all components Refer to the front of this book for detailed information and illustrations regarding the location and identification of harnesses, relays, fuses, grounds, control
connected and fitted. modules and control module pins.

DATE OF ISSUE: August 2003

 X-TYPE 2004.25 / 2004.5 Powered Windows Powered Windows Fig. 14.1

* NOTE: Remote Global Close – ROW vehicles only.

OY B
60
JB172-1

I B
IP5-3 B O 43
WG 14.2 SLIDING ROOF
* REMOTE
GLOBAL CLOSE RC35-3

I B B B P B B B B
IP5-23 CA240-2 CA40-11 RC35-1 RC35-2 RCS1 CA36-16 CAS10

G15AL

RF MODULE
(ESTATE / WAGON,
JAPAN, S. KOREA) 45
OY RELAY
SET B G I GLOBAL DD2-7
B B B B DD3-5 CA16-5 CA86-16 CLOSE
61 GW
CAS10 DDS1 II
CA15-2 DD3-6 DD2-2
G15AL DD3-7 WG WG WG POSITION
NOTE: CAS10 – LHD only. KEY BARREL SWITCH GLOBAL O MOTOR SENSORS
(G4AL) CLOSE CA87-17 CAS22 CONTROL
CA15-10 DD2-6
U (LHD) W (RHD) B B B B
DRIVER DOOR LATCH B DD2-4 DD2-8 DDS1 CA15-2 CAS10

IP6-1 G (LHD) O (RHD) NOTE: CAS10 – LHD only. G15AL

G5AS (G4AL)
DD2-3
(G5AR)
GENERAL ELECTRONIC
MODULE DRIVER WINDOW MOTOR

62 GW REAR
II WINDOWS
DD1-15
ISOLATE
CONTROL REAR WINDOW
ISOLATE
O BW BW
DD1-5 CA15-7
58
OY RELAY
PD2-7
U U (LHD) W (RHD) 59 GU
II

(RHD)
LH FRONT DD1-12 PD2-2
WINDOW POSITION
G G (LHD) O (RHD) WG WG MOTOR SENSORS
(RHD) CONTROL

(RHD)
DD1-13 CA20-10 PD2-6
W W (LHD) U (RHD) W W W B B B B
RH FRONT DD1-19 (RHD) CA15-5 CA20-5 PDS3 PD2-4 PD2-8 PDS1 CA20-2 CAS10
WINDOW
O O (LHD) G (RHD) O O O NOTE: CAS10 – RHD only.
G4AL
PDS2 (G15AL)
DD1-20 CA15-6 CA20-6 PD2-3
RW RW R
LH REAR DD1-9 CA15-13 CA25-1 R PASSENGER WINDOW MOTOR
WINDOW
YB YB Y
DD1-10 CA15-14 CA25-2 Y
R R R
RH REAR DD1-1 CA15-11 CA30-1
WINDOW
B B B B Y Y Y
CAS10 CA15-2 DDS1 DD1-14 DD1-2 CA15-12 CA30-2 OY RELAY
46
G15AL NOTE: CAS10 – LHD only. BL2-7
(G4AL) DRIVER DOOR SWITCH PACK
60 GW
II
BL2-2
WG WG POSITION
MOTOR SENSORS
CONTROL
B B B B W CA25-6 BL2-6
CAS10 CA20-2 PDS1 PD10-8 PD10-3 R B B B B
G4AL O BL2-4 BL2-8 BLS3 CA25-3 CAS10
NOTE: CAS10 – RHD only.
(G15AL)
PD10-7 Y G15AL
BL2-3
PASSENGER DOOR
SWITCH PACK
LH REAR WINDOW MOTOR

R
BL1-3 NOTE: Vehicles with Manual Rear Windows –
Y Rear Window Switches, Motors and associated
BL1-7
wiring deleted.
BW BW OY RELAY
59
BL1-8 CA25-7 CAS59 BR2-7

LH REAR DOOR 58 GU
II
SWITCH PACK BR2-2
POSITION
WG WG MOTOR SENSORS
CONTROL
CA30-6 BR2-6
R R B B B B
BR1-3 BRS2 BR2-4 BR2-8 BRS4 CA30-3 CAS8

Y Y G4AL
BR1-7 BRS1 BR2-3
BW BW
BR1-8 CA30-7 RH REAR WINDOW MOTOR
RH REAR DOOR
SWITCH PACK

1 6 Fig. 01.1 34 79 Fig. 01.3 11

II
31
II
Fig. 01.5 67
B
76
B
Fig. 01.7 98
E
107 Fig. 01.9
E
I Input B
+ Battery Voltage + Sensor/Signal Supply V C CAN D
2 D2B Network VARIANT: All Vehicles
VIN RANGE: All
7 33 Fig. 01.2 1 10 Fig. 01.4 32 66 Fig. 01.6 77 97 Fig. 01.8 O Output P Power Ground – Sensor/Signal Ground S SCP D Serial and Encoded Data
I I II II E E DATE OF ISSUE: August 2003
CONTROL MODULE PIN-OUT INFORMATION Fig. 14.2
General Electronic Module

Pin Description and Characteristic COMPONENTS
I CA86-16 SET SWITCH: OPEN CIRCUIT / GROUND Component Connector(s) Connector Description Location
DOOR LATCH – DRIVER DD3 8-WAY / BLACK DRIVER DOOR
O CA87-17 GLOBAL CLOSE REQUEST: 20 mS PULSED SIGNAL
DD9 2-WAY / BLACK
O CA87-20 VEHICLE SPEED SIGNAL: PULSED SIGNAL, 8000 PULSES PER MPH
GENERAL ELECTRONIC MODULE CA86 23-WAY / GREY BEHIND INSTRUMENT PANEL / RH SIDE
CA87 23-WAY / GREEN
I IP5-03 SEDAN (EXCEPT JAPAN AND S. KOREA): EXTERNAL ANTENNA IP5 23-WAY / BROWN
S IP5-18 SCP - IP6 23-WAY / NATURAL
S IP5-19 SCP + JB172 23-WAY / BLUE
I IP5-23 REMOTE RF SIGNAL RF MODULE RC35 3-WAY / BLACK ROOF CONSOLE
ROOF CONSOLE – PRINTED CIRCUIT BOARD RC23 20-WAY / WHITE ROOF CENTER FRONT
SG IP6-01 LOGIC GROUND: GROUND ROOF CONSOLE – WITHOUT PRINTED CIRCUIT BOARD RC30 4-WAY / BLACK ROOF CENTER FRONT
RC31 2-WAY / BLACK
B+ JB172-01 BATTERY POWER SUPPLY (LOCKING): B+ RC33 4-WAY / BLACK
RC34 6-WAY / BLACK
SLIDING ROOF MODULE RC14 10-WAY / GREY ROOF CONSOLE
NOTE: Refer to the Appendix at the rear of this book for Network Messages.

HARNESS IN-LINE CONNECTORS

Connector Connector Description Location
CA15 20-WAY / BLACK / CABIN HARNESS TO DRIVER DOOR HARNESS DRIVER DOOR / DOOR CASING
CA16 20-WAY / BLACK / CABIN HARNESS TO DRIVER DOOR HARNESS DRIVER DOOR / DOOR CASING
CA36 16-WAY / GREEN / CABIN HARNESS TO ROOF HARNESS LH ‘A’ POST / WINDSHIELD PILLAR
CA40 16-WAY / GREY / CABIN HARNESS TO ROOF HARNESS RH ‘A’ POST / WINDSHIELD PILLAR
CA240 12-WAY / GREY / CABIN HARNESS TO INSTRUMENT PANEL HARNESS LH LOWER ‘A’ POST / ‘A’ POST TRIM

GROUNDS
Ground Harness Location
G4 CA LOWER RH ‘A’ POST
G5 IP UPPER RH ‘A’ POST
G15 CA LOWER LH ‘A’ POST

FOR CONTROL MODULE PIN-OUT INFORMATION, UNFOLD PAGE TO LEFT.

The following abbreviations are used to represent values for Control Module Pin-Out data

I Input PG Power Ground C CAN Network D Serial and Encoded Data

O Output SS Sensor / Signal Supply V S SCP Network V Voltage (DC)
B+ Battery Voltage SG Sensor / Signal Ground D2 D2B Network PWM Pulse Width Modulated

CAUTION: The information on this data page is furnished to aid the user in understanding circuit oper ation. THIS INFORMATION SHOULD BE USED FOR
REFERENCE ONLY.

NOTE: The values listed are approximately those that can be expected at the control module connector pins with all circuit connections made and all components Refer to the front of this book for detailed information and illustrations regarding the location and identification of harnesses, relays, fuses, grounds, control
connected and fitted. modules and control module pins.

DATE OF ISSUE: August 2003

 X-TYPE 2004.25 / 2004.5 Sliding Roof Sliding Roof Fig. 14.2

OY B
60
JB172-1

Y S +
20.3
VEHICLE IP5-19
SCP
SPEED U * NOTE: Remote Global Close – ROW vehicles only.
20.3 S –
IP5-18

I B
IP5-3 B O 43
* REMOTE
RC35-3
GLOBAL CLOSE
I B B B P B B B B
IP5-23 CA240-2 CA40-11 RC35-1 RC35-2 RCS1 CA36-16 CAS10

G15AL

RF MODULE
(ESTATE / WAGON,
SET B G I GLOBAL JAPAN, S. KOREA)
B B B B DD3-5 CA16-5 CA86-16 CLOSE
CAS10 CA15-2 DDS1 DD3-6
G15AL NOTE: CAS10 – LHD only. DD3-7
(G4AL) KEY BARREL SWITCH

* NOTE: Roof Console without printed circuit board.

DRIVER DOOR
LATCH
44
O B
RC14-1

57 WU B OPEN / DOWN O
WU
II
RC14-7 RC14-9 RC23-5
RC34-2*

GLOBAL O WG WG WG I Y
TILT / CLOSE O
CLOSE CA87-17 CAS22 CA36-6 RC14-2 RC14-8 RC23-4
RC34-5*

B
RC23-1
RC34-6*
VEHICLE O U U I SLIDING ROOF
SPEED MOTOR ASSEMBLY
CA87-20 CA36-2 RC14-6

P B B B B ROOF CONSOLE
RC14-10 RCS1 CA36-16 CAS10

G15AL
SLIDING ROOF
MODULE
B
IP6-1
G5AS
(G5AR)
GENERAL ELECTRONIC
MODULE

1 6 Fig. 01.1 34 79 Fig. 01.3 11

II
31
II
Fig. 01.5 67
B
76
B
Fig. 01.7 98
E
107 Fig. 01.9
E
I Input B
+ Battery Voltage + Sensor/Signal Supply V C CAN D
2 D2B Network VARIANT: Sliding Roof Vehicles
VIN RANGE: All
7 33 Fig. 01.2 1 10 Fig. 01.4 32 66 Fig. 01.6 77 97 Fig. 01.8 O Output P Power Ground – Sensor/Signal Ground S SCP D Serial and Encoded Data
I I II II E E DATE OF ISSUE: August 2003