Professional Documents
Culture Documents
Kirkland BBQ Manual
Kirkland BBQ Manual
FOR YOUR SAFETY It you smell gas: 1. Shut off gas to the appliance. 2. Extinguish any open flame. 3. Open lid 4. If odor continues, immediately call you gas supplier or your fire department. FOR YOUR SAFETY 1. Do not store or use gasoline or other flammable vapors and liquids in the vicinity of this or any other appliance. 2. An LP cylinder not connected for use shall not be stored in the vicinity of this or any other appliance.
Note: This appliance is NOT intended to be installed in or on recreational vehicles or boats. PLEASE RETAIN THIS MANUAL FOR FUTURE
TABLE OF CONTENTS
SECTION ONE: Precaution Placement of the grill SECTION TWO: Assembly/installation of side shelf Installation of utensil rack Installation of push bar Installing the strengthening bar And serving tray Rotisserie kit assembly Gas hook-up Leak testing Installer final checklist SECTION THREE: Operating instruction Lighting instruction grill /rotisserie Lighting illustration SECTION FOUR: Using the side burner 2-3 3 SECTION FIVE: Care and maintenance of side burner Troubleshooting SECTION SIX: Grill parts list 4 5 6 7 8 9 9 10 SECTION SEVEN: Grilling hints Grill cooking chart SECTION EIGHT: Grill recipe suggestions SECTION NINE: Limited warranty 14 15
16
17 18
21
24
11 12 13
14
PRECAUTIONS
TESTED IN ACCORDANCE WITH ANSI Z21.58a-1995 STANDARD FOR OUTDOOR COOKING GAS APPLIANCES. THIS GRILL IS FOR OUTDOOR USE ONLY. Check your local building codes for the proper method of installation. In the absence of local codes, this unit should be installed in accordance with the National Fuel Gas Code No. Z223.11988 and the National Electrical Code ANSI/NFPA No. 70-1990. CALIFORNIA PROPOSITION 65WARNING The burning of gas fuel generates some byproducts, which are on the list of substances which are known by the State of California to cause cancer or reproductive harm. California law requires businesses to warn customers of potential exposure to such substances. To minimize exposure to these substances, always operate this unit according to the use and care manual, ensuring you provide good ventilation when cooking with gas.
Do not repair or replace any part of the grill unless specifically recommended in this manual. All other service should be referred to a qualified technician. CHILDREN SHOULD NOT BE LEFT ALONE OR UNATTENDED IN AN AREA WHERE THE GRILL IS BEING USED. NEVER ALLOW THEM TO SIT, STAND OR PLAY ON OR AROUND THE GRILL AT ANY TIME. DO NOT STORE ITEMS OF INTEREST TO CHILDREN AROUND OR BELOW THE GRILL OR IN THE CART. NEVER ALLOW CHILDREN TO CRAWL INSIDE OF THE CART. Never let clothing, pot holders or other flammable materials come in contact with or too close to any grate, burner or hot surface until it has cooled. Fabric may ignite and result in personal injury. For personal safety, wear proper apparel. Loose fitting garments or sleeves should never be worn while using this appliance. Some synthetic fabrics are highly flammable and should not be worn while cooking. Only certain types of glass, heat-proof glass ceramic, earthenware, or other glazed utensils are suitable for grill use. Theses types of materials may break with sudden temperature changes. Use only on low or medium heat settings according to the manufacturers directions. Do not heat unopened food containers as a build-up of pressure may cause the container to burst. Use a covered hand when opening the grill lid. Never lean over an open grill. WHEN LIGHTING A BURNER, ALWAYS PAY CLOSE ATTENTION TO WHAT YOU ARE DOING. BE CERTAIN YOU ARE TURNING THE IGNITER LABELED FOR THE BURNER YOU INTEND ON USING.
PRECAUTIONS
When using the grill, do not touch the grill rack, burner grate or immediate surrounding area as these areas become extremely hot and could cause burns. Use only dry potholders. Moist or damp potholders on hot surfaces may cause burns from steam. Do not use a towel or bulky cloth in place or potholders. Do not let potholders touch hot portions of the grill rack. Grease is flammable. Let hot grease cool before attempting to handle it. Avoid letting grease deposits collect in the bottom of the grill. Clean often. DO NOT USE ALUMINUM FOIL TO LINE THE GRILL RACKS OR GRILL BOTTOM. This can severely upset combustion air flow or trap excessive heat in the control area. The result of this can be melted knobs, rotary igniters and increased chance of personal injury. For proper lighting and performance of the burners keep the ports clean. It is necessary to clean them periodically for optimum performance. The burners will only operate in one position and must be mounted correctly for safe operation. Clean the grill with caution. Avoid steam burns; do not use a wet sponge or cloth to clean the grill while it is hot. Some cleaners produce noxious fumes or can ignite if applied to a hot surface. INSECT WARNING!!! Spiders and insects can nest in the burners of this and any other grill, and cause the gas to flow from the front of the burner. This is a very dangerous condition which can cause a fire to occur behind the value panel, thereby damaging the grill and making it unsafe to operate. Inspect the grill twice a year. Be sure all grill controls are turned off and the grill is cool before using any type of aerosol cleaner on or around the grill. The chemical that produces the spraying action could, in the presence of heat, ignite or cause metal parts to corrode. Do not use the grill for cooking excessively fatty meats or products which promote flare-ups. Do not operate the grill under unprotected combustible construction. Use only in well ventilated areas. Do not use in buildings, garages, sheds, breezeways or other such enclosed areas. THIS UNIT IS FOR OUTDOOR USE ONLY. Keep the area surrounding the grill free from combustible materials, trash, or combustible fluids and vapors such as gasoline or charcoal lighter fluid. Do not obstruct the flow of combustion and ventilation air. If the unit is stored indoors ensure that it is cool. If propane is used, the cylinder must be unhooked and the propane cylinder stored outside in a well ventilated area, out of reach of children. DO NOT USE BRIQUETTES OF ANY KIND IN THE GRILL. The Kirkland Signature Grill is designed for optimum performance without the use of briquettes. Do not place briquettes on the radiant as this will block off the area for the grill burners to vent. Adding briquettes can damage ignition components and knobs, and void the warranty. Keep the back of the cart free and clear from debris. Keep any electrical supply cord, or the rotisserie motor cord away from the heated areas of the grill. Never use the grill in windy conditions. If located in a consistently windy area (oceanfront, mountaintop, etc.) a windbreak will be required. Always adhere to the specified clearance. NEVER USE A DENTED OR RUSTY PROPANE
GAS HOOK-UP
The pressure regulator and hose assembly supplied with the grill must be used. Replacement pressure regulator and hose assembly must be specified by the grill manufacturer. This is a liquid propane configured grill. Do not attempt to use a natural gas supply unless the grill has been reconfigured got natural gas use. Total gas consumption (per hour) of The Kirkland Signature Grill with all burners on HI: Main burners Rotisserie burner Side burner Total 45,000 Btu/hr. 10,000 Btu/hr. 10,000 Btu/hr. 65,000 Btu/hr. Manifold pressure: (operating): 10 water column. L.P. GAS HOOK-UP: Ensure that the black plastic grommets are in place and that the hose does not come into contact with the heat shield or the grill head. CONNECTION: Orifices for use with L.P. gas come equipped with a high capacity hose/regulator assembly for connection to a standard 20lb. L.P. cylinder (18-1/4 high, 12-1/4 diameter). To connect the L.P. gas supply cylinder, please follow the steps below: 1. Make sure tank valve is in its full off position (turn clockwise to stop) 2. Check tank valve to assure it has proper external male threads (type 1 connection per ANSIZ21.81) 3. Make sure all burner valves are in their off position. 4. Inspect valve connections port and regulator assembly. Look for any damage or debris. Remove any debris. Inspect hose for damage. Never attempt to use damaged or plugged equipment. See your local L.P. gas dealer for repair. 5. When connecting regulator assembly to the valve, hand tighten nut clockwise to a positive stop. Do not use a wrench to tighten. Use of a wrench may damage quick coupling nut and result in a hazardous condition. 6. Open tank valve fully (counterclockwise). Use a soapy water solution to check all connections for leaks before attempting to light grill. If a leak is found, turn tank valve off and do not use grill until a local L.P. gas dealer can make repairs. To disconnect L.P. gas cylinder: 1. Turn the burner valve off. 2. Turn the tank valve off fully (turn clockwise to stop). 3. Detach the regulator assembly from tank valve by turning the quick coupling nut counterclockwise.
The installation of this appliance must conform with local codes or, in the absence of local codes, with the national fuel gas code, ANSI Z223. 1a-1988. Installation in Canada must be in accordance with the Standard Can1-b149.1 and/or .2 (installation code for gas burning appliances and equipment) and local codes. L.P. Tank Requirements A dented or rusty L.P. tank may be hazardous and should be checked by your L.P. supplier. Never use a cylinder with a damaged valve. The L.P. gas cylinder must be constructed and marked in accordance with the specifications for L.P. gas cylinders of the U.S. Department of Transportation (DOT), or the National Standard of Canada, CAN/CSA-B339, Cylinders, Spheres and Tubes for Transportation of Dangerous Goods; and Commission. The cylinder must be provided with a listed overfilling presentation device and a shut valve terminating in an L.P. gas supply cylinder valve outlet specified, as applicable, for connection type QCC1 in the standard for compressed gas cylinder valve outlet and inlet connection ANSI/CGA-V-1. The cylinder supply system must be arranged for vapor withdrawal. The cylinder must include a collar to protect the cylinder valve.
LEAK TESTING
GENERAL Although all gas connections on the grill are leak tested at the factory prior to shipment, a complete gas tightness check must be performed at the installation site due to possible mishandling in shipment, or excessive pressure unknowingly being applied to the unit. Periodically check the whole system for leaks, or immediately check if the smell of gas is detected. BEFORE TESTING Make sure that all packing material is removed from the grill including the burner tie-down straps.
DO NOT SMOKE WHILE LEAK TESTING. NEVER LEAK TEST WITH AN OPEN FLAME. Make a soap solution of one part liquid detergent and one part water. You will need a spray bottle, brush, or rag to apply the solution to the fittings. For the initial leak test, make sure the L.P. cylinder is full. TO TEST Make sure all control valves are in the OFF position. Turn the gas supply on. Check all connections from the L.P. cylinder up to and including the connection to the manifold pipe assembly (the pipe that goes to the burner). Soap bubbles will appear where a leak is present. If a leak is present, immediately turn off gas supply, tighten any leaking fittings, turn gas on, and recheck. Should the gas continue to leak from any or all of the fittings, turn off the gas supply, and contact our customer service at 1-800-913-8999. Only those parts recommended by the manufacturer should be used on the grill. Substitution can void the
warranty. Do not use the grill until all connections have been checked and do not leak.
Gas flow check: Each grill burner is tested and adjusted at the factory prior to shipment; however, variations in the local gas supply may make it necessary to adjust the burners. The flames of the burners should be visually checked.
Flames should be blue and stable with no yellow tips, excessive noise or lifting. If any of these conditions exist, check if the air shutter or burner ports are blocked by dirt, debris, spider webs, etc.
PROPANE CYLINDER CAUTIONS a) Do Not store a spare LP-gas cylinder under or near this appliance. b) NEVER fill the cylinder beyond 80 percent full. c) If the information in a and b is not followed exactly, a fire causing death or serious injury may occur.
10
OPERATING INSTRUCTION
General use of the grill and rotisserie Each burner is rated at 15,000 Btu/hr. The grill burners encompass the entire cooking area and are side ported to minimize blockage from falling grease and debris. Above the burners are stainless steel radiants. The igniter knobs are located on the lower center portion of the valve panel. Each rotary igniter is labeled on the Lighting Instructions Plate. USING THE GRILL: Grilling requires high heat for searing and proper browning. Most foods are cooked at the HI heat setting for the entire cooking time. However, when grilling large pieces of meat or poultry, it may be necessary to turn the heat to a lower setting after the initial browning. This cooks the food through without burning the outside. Foods cooked for a long time or basted with a sugary marinade may need a lower heat setting near the end of the cooking time. Make sure the grill has been leak tested and is properly located. Remove any packing material. Light the grill burners using the instructions in this manual. Turn the control knob to HI and preheat the grill for 15 minutes. The grill lid is to be closed during the appliance preheat period. Place the food on the grill and cook to the desired doneness. Adjust heat setting, if necessary. The control knob may be set to any position between HI and LO. NOTE: The Kirkland Signature grill is designed to grill efficiently without the use of lava rocks or briquettes of any kind. Heat is radiated by the stainless steel flame tamers positioned beneath the solid stainless steel rods. NOTE: The hot grill sears the food, sealing in the juices. The longer the preheat, the faster the meat browns and the darker the grill marks. DO NOT LEAVE THE GRILL UNATTENDED WHILE COOKING. USING ROTIS BURNER: Your grill is capable of performing back burner rotis cooking. Light the rear burner as described in the lighting instructions. Once lit, the rotis burner will reach cooking temperatures in about 1 minute. The rotis motor is capable of turning up to a 12lb. cut of meat or poultry. The motor slides onto the stainless steel motor mount. The rotisserie motor must be electrically grounded in accordance with local codes or, in the absence of local codes, with the National Electrical Code, ANSI/NFPA 70-1990. The skewer for the rotis is assembled into the motor assembly by placing the pointed end into the motor, and resting the grooved bushing on the support at the opposite side of the grill. The thumbscrew should be inside the grill body. With the skewer pushed as far as possible into the motor, the skewer should rest on the left side of the grill body. To load the skewer begin with the handle in place, and slide one of the meat forks (prongs toward the food) onto the skewer. Center the product to be cooked on the skewer then push the meat forks firmly together. Tighten the wing nuts as tight as possible. It may also be necessary to wrap the food with butchers string (never use nylon or plastic string) to secure any loose portions. Once the food is secure insert the skewer into the motor. It is normal for the skewer to flex when larger cuts of meat are being cooked. It may also be necessary to remove the grill rods for larger cuts of meat. If the meat scrapes on the grill rods during any part of the rotation, then the grill rods must be removed. Assemble the counterweight with washers and handle to counter balance the heaviest side of the meat. By suing the counterweight the rotisserie motor should turn smoothly through all 360 degrees of rotation. After your first use of the rotis burner it is likely that the stainless steel adjacent to the burner will darken to a dark blue color. This is a normal property of the non-rusting, type 304 stainless steel used on the grill. CAUTION: PLEASE TAKE OFF THE WARMING RACK WHEN USING THE ROTIS BURNER. THE HIGH HEAT COMING FROM THE ROTIS BURNER MAY CAUSE THE WARMING RACK TO BEND. WARNING ELECTRICAL GROUNDING INSTRUCTIONS. This appliance (rotisserie motor) is equipped with a plug and should be plugged directly into a properly grounded receptacle. DO NOT cut or remove the grounding prong from this plug. Keep the rotis motor electric cord away from the heated surfaces of the grill. When not in use remove and store the motor in a dry location.
11
12
LIGHTING ILLUSTRATIONS
13
14
noticeable scratches in the stainless steel, sand very lightly with dry 100 grit emery paper in the direction of the grain. TOP BURNER GRATE:
The top burner grate is stainless steel. To avoid burns do not clean a hot grate. They may be wiped while in place with hot, soapy water, rinsed and wiped dry. Never immerse a hot grate in water.
TROUBLESHOOTING
SPIDER AND INSECT WARNING!!! Spiders and insects can nest in the burners of this or any other grill, and cause the gas to flow from the front of the burner. This is very dangerous condition which can cause a fire to occur behind the valve panel, thereby damaging the grill and making it unsafe to operate. WHEN TO LOOK FOR SPIDERS You should inspect the burners at least once a year or immediately if any of the following conditions occur: 1. 2. 3. 4. The smell of gas in conjunction with the burner flames appearing yellow. The grill does not reach temperature. The grill heats unevenly. The burners make popping noises.
BEFORE CALLING FOR SERVICE If the grill does not function properly, use the following checklist before contacting your dealer for service. You may save the cost of a service call. CHECKLIST
WHAT TO DO Check to see if LP tank is empty Clean wire(s) and/or electrode by rubbing with alcohol and clean swab Wipe with dry cloth Reconnect wire and/or electrode assembly Do other burners on the unit operate? Check the orifice for blockage. Call our customer service line.
Burner flame is yellow or orange, in conjunction with the odor of gas. Low heat with knob in HI position.
Is the fuel hose bent or kinked? Is the grill in a dusty area? Is there adequate gas supply available? If it is only one burner that appears low, does the orifice or burner need cleaning? Is the gas supply, or gas pressure low? Is the grill being preheated for 15 minutes?
15
16
GRILLING HINTS
The doneness of meat, whether rare, medium, or well done, is affected to a large degree by the thickness of the cut. Expert chefs say it is impossible to have a rare doneness with a thin cut of meat. The cooking time is affected by the kind of meat, the size and shape of the cut, the temperature of the meat when cooking begins, and the degree of doneness desired. When defrosting meats it is recommended that it be done overnight in the refrigerator as opposed to a microwave. This in general yields a juicier cut of meat. Use a spatula instead of tongs or a fork to turn the meat, as a spatula will not puncture the meat and let the juices run out. To get the juiciest meats, add seasoning or salt after the cooking is finished on each side and turn the meat only once (juices are lost when the meat is turned several times). Turn the meat just after the juices begin to bubble to the surface. Trim any excess fat from the meat before cooking. To prevent steaks or chops from curling during cooking, slit the fat around the edges at 2-inch intervals. DO NOT LEAVE THE GRILL UNATTENDED WHILE COOKING.
17
Slice. Dot with butter or margarine. Wrap in heavy-duty foil. Grill, turning occasionally. Medium 12 to 20 minutes
Turnips Onion
Grill, turning once. Brush occasionally with melted butter or margarine. 1/2 inch slices Medium 8 to 20 minutes Wrap individually in heavyduty foil. Grill, rotating occasionally. Whole 6 to 8 ounces Medium High 40 to 60 minutes 45 to 60 minutes
Dot with butter or margarine. Wrap in heavy-duty foil. Grill, turning occasionally. Medium 15 to 30 minutes
Medium
15 to 30 minutes
Medium High
10 to 18 minutes 8 to 15 minutes
Grill, turning once when juices rise to the surface. Do not leave hamburgers unattended since a flare-up could occur quickly.
WEIGHT OR THICKNESS
FLAME SIZE
APPROXIMATE TIME
18
Tenderloin, Porterhouse, T-Bone, Sirloin Remove excess fat from edge. Slash remaining fat at 2-inch intervals. Grill, turning once.
Remove excess fat from edge. Slash remaining fat at 2-inch intervals. Grill, turning once.
Medium Medium
15 to 40 minutes 25 to 60 minutes
Remove excess fat from edge. Slash remaining fat at 2-inch intervals. Grill, turning once. Cook well done.
40 to 60 minutes
Grill, turning occasionally. During last few minutes brush with barbecue sauce, turn several times.
High Medium
4 to 8 minutes 5 to 10 minutes
Remove excess fat from edge. Slash remaining fat at 2-inch intervals. Grill, turning once. Slit skin. Grill, turning once. Place skin side up. Grill, turning and brushing frequently with melted butter, margarine, oil or marinade.
Broiler/fryer 2 to 3 pounds Halved or Quartered welldone Breasts well-done WEIGHT OR THICKNESS FOOD
Low or Medium
Medium
19
FISH AND SEAFOOD Grill, turning once. Brush withmelted butter, margarine or oil to keep moist. 3/4 to 1 inch Medium to High 8 to 15 minutes
4 to 8 ounces
Medium to High
12 to 20 minutes
20
21
minutes longer or until potatoes are tender. Let stand 5 minutes before serving. VEGETABLE KABOBS 3 medium-sized zucchini 12 cherry tomatoes 12 fresh mushrooms Grated Parmesan cheese Parboil whole zucchini 5 minutes on your side burner or until just tender. Drain and cut into inch slices. Thread zucchini, tomatoes and mushrooms alternately on each of six skewers. Brush with marinade made of Italian dressing, Worcestershire sauce, mustard and thyme. Grill 5 to 7 minutes turning and basting occasionally. Sprinkle liberally with Parmesan cheese. FAJITAS 1-1/2 lb. flank steak or boned chicken breasts 2 tbs. oil cup limejuice tsp. salt tsp. celery salt tsp. garlic powder tsp. pepper tsp. oregano tsp. cumin Flour tortillas lemon Pound flank steak to inch thickness or flatten chicken breasts. Mix oil, lime juice and seasonings in a zip lock bag. Add meat and shake bag to coat the meat. Refrigerate overnight or at least 6 to 8 hours. Wrap tortillas in foil. Remove meat from marinade. Cook on a pre-heated gas grill for 5 to 8 minutes on each side. While meat is cooking, heat tortillas on grill. Slice meat across grain in thin slices. Place on hot platter. Squeeze lemon juice over. Wrap meat and any of the following toppings in tortillas: chopped tomatoes, guacamole, sour cream, taco sauce. BEEF AND LAMB KABOBS
Serve 4 lb. boneless sirloin or beef cut into 1 cubes lb. boneless loin of lamb cut into 1 cubes 2/3 c. water, divided c. chopped onion 2 tbs. soy sauce c. vegetable oil, divided 1 tbs. dark brown sugar 1 tbs. fresh lemon juice 2 cloves garlic, minced tsp. ground cumin tsp. ground coriander tsp. ground turmeric 1/8 tsp. ground red pepper 1/8 tsp. ground ginger 1 red pepper cut into chunks 1 large banana, cut into chunks 8 small mushrooms 1/3 c. smooth peanut butter In blender, process 1/3 c. water, onion, soy sauce, 2 tsp. oil and the next 8 ingredients until smooth. Pour over meat cubes and marinate about 4 hours, turning occasionally. Drain and reserve marinade. Onto to four 12 skewers alternately thread meat, pepper, banana and mushrooms. Preheat grill. Brush the kabobs with oil. Grill 7-8 minutes each side. Bring marinade to boil on the side burner in a saucepan. Add remaining 1/3 c. water and peanut butter. Stir to blend. Heat through. If sauce gets too thick, add 1 tbs. water. Serve sauce with kabobs. EGGPLANT CAVIAR 1 large eggplant 2 tbs. olive oil 2 tbs. wine vinegar 2 tbs. finely chopped onion clove garlic, minced 1 medium tomato, chopped salt and pepper Roast eggplant on gas grill over medium flame, turning occasionally until thoroughly cooked. This may take 30 minutes. Remove from grill and cool for handling. Strip off the skin and
chop eggplant finely. Add all the seasonings. Chill thoroughly and serve on toast. CHICKEN TANDOORI STYLE 8 large chicken thighs or drumsticks 1 c. plain nonfat yogurt c. lemon juice 2 tsp. salt tsp. cayenne tsp. black pepper tsp. crushed garlic tsp. grated ginger 1 tbs. corn oil Combine all the ingredients in a large mixing bowl and marinate the chicken for 8 hours in the refrigerator. Drain the chicken and spread on the spit running the rod on the fleshier side of the bone. Rotis using the rotis burner. Cook on medium high heat for 40 minutes basting occasionally with the remainder of the marinade mixture. Serve with sliced onions and lemon wedges. SPARE RIBS Marinade: 1 c. soy sauce c. honey c. vinegar c. dry sherry 2 tsp. chopped garlic 2 tsp. sugar 1 c. water 1 chicken bouillon cube 1 can beer for basting sauce Marinade ribs for 3 hours. Use marinade for basting by adding beer to it. Place pan under the ribs and baste frequently. To cook ribs select lean, meaty ribs and accordion pleat them with your spit. Slide four prong meat hook down the length of spit and tighten. At the beginning of the rack and to its center, penetrate the second rib with the pointed end of the spit and push it between the meat. Skip a couple and continue the process until the entire rack is
22
accordion pleated. Fasten the second meat hook into the rack. Turn your rotis burner on high. Rotis for 50 minutes or until done. PORK ROAST Apple cider vinegar basting sauce: 1 c. apple cider vinegar 6 oz. water stick butter Salt, pepper, parsley and garlic seasoning 2 oz. lemon juice 10 lbs. pork roast Time: 1-1/2 hours to 2 hours Bring pork to room temperature before placing it on the spit rod. Place on the rod and test for balance. Light rotis burner. Turn control knob to high. Use the above basting sauce for rotissing. TURKEY 12 lb. turkey Beer basting sauce: 1 can beer 12 oz. water 1 stick butter 1 tsp. salt 1 tsp. pepper tsp. garlic flakes 1 tsp. parsley Thaw the bird completely. Wash inside out. Securely tie the legs and wings. Light rotis burner. Turn to high. Combine all the ingredients for basting sauce in a shallow pan. Place it under the turkey 15 to 20 minutes. Cook for approximately 3 hours. The basting sauce combined with turkey drippings makes a delicious gravy.
23
Virco Associates Inc. warrants to the original consumer purchaser of each Outdoor Gas Grill that when subject to normal residential use, it is free from defects in workmanship and materials for the periods specified below. This warranty excludes grills used in rental or commercial applications. There will be a shipping and handling charge for the delivery of the warranty part(s).
Component
Burners: Stainless Steel Flame Tamer: Stainless Steel Cooking Grids: Valves: Frame, Housing, Cart, Control Panel, Igniter, and Related Parts: All Stainless Steel Parts
Our obligation under this warranty is limited to repair or replacement, at our option, of the product during the warranty period. The extent of any liability of Virco Associate Inc. under this warranty is limited to repair or replacement. This warranty does not cover normal wear of parts, damage resulting from any of the following: negligent use or misuse of the product, use on improper fuel/gas supply, use contrary to operating instructions, or alteration by any person other than our factory service center. The warranty period is not extended by such repair or replacement.
Warranty claim procedure: If you require service or parts for your grill, please contact our Warranty Service Center for factory direct assistance. Our hours of operation are 8 AM to 5 PM PST. Our number is 1-909-5988799 and our FAX number is 1-909-5987699. Please direct all correspondence to: Virco Associate, Inc. 145 Brea Canyon Road, Walnut, CA 91789 ATTN: Warranty Service Center.
Product repair as provided under this warranty is your exclusive remedy. Virco Associate, Inc. shall not be liable for any incidental or consequential damages for breach of any express or implied warranty on its products. Except to the extent prohibited by applicable law, any implied warranty or merchantability or fitness for a particular purpose on this product to the duration of the above warranty. Some states do not allow the exclusion or limitation of incidental or consequential damages, or allow limitations on how long an implied warranty lasts, so the above limitations or exclusions may not apply to you. This warranty gives you specific legal rights, and you may have other rights, which vary from state to state.
24