CX-JDS22/JDS33

SERVICE MANUAL

E Model

Ver. 1.0 2006.02

CX-JDS22/JDS33 are the Amplifier, CD player, Tape

Deck and Tuner section in DBX-DS22/DS33.

Photo : CX-JDS33

CD
Section
TAPE
Section

Model Name Using Similar Mechanism

CX-JDS30

CD Mechanism Type

BU-F1BD81AA

Optical Pick-up Name

KSM-215DCP/C2NP

Model Name Using Similar Mechanism

CX-JDS20/JDS30

Tape Transport Mechanism Type

JDS22

CMAL5Z220A

JDS33

CMAL1Z240A

SPECIFICATIONS
Amplifier section

CD player section

JDS33

System

The following measured at AC 120, 127, 220, 230,

240 V 50/60 Hz
DIN power output (rated): 120 + 120 watts (6 ohms at
1 kHz, DIN)
Continuous RMS power output (reference):
150 + 150 watts (6 ohms at
1 kHz, 10% THD)

Laser Diode Properties

JDS22
The following measured at AC 120, 127, 220, 230,
240 V 50/60 Hz
DIN power output (rated): 96 + 96 watts (6 ohms at
1 kHz, DIN)
Continuous RMS power output (reference):
120 + 120 watts (6 ohms at
1 kHz, 10% THD)
Inputs
AUDIO IN (stereo mini jack):
voltage 250 mV,
impedance 47 kilohms
MIC (phone jack) (except for European model):
sensitivity 1 mV,
impedance 10 kilohms
Outputs
PHONES (stereo mini jack):
accepts headphones of
8 ohms or more
SPEAKER:
accepts impedance of 6 to
16 ohms

9-887-087-01
2006B1678-1
2006.02

Frequency response
Signal-to-noise ratio
Dynamic range

Compact disc and digital

audio system
Emission duration:
continuous
Laser Output: Less than
44.6 W
(This output is the value
measurement at a distance
of 200 mm from the
objective lens surface on
the Optical Pick-up Block
with 7 mm aperture)
2 Hz 20 kHz (0.5 dB)
More than 90 dB
More than 90 dB

FM tuner section
Tuning range
Antenna
Antenna terminals
Intermediate frequency
AM tuner section
Tuning range
Pan-American models:

Other models:

Tape deck section

Recording system
Frequency response

4-track 2-channel, stereo

50 13,000 Hz (3 dB),
using Sony TYPE I
cassettes

Antenna
Antenna terminals
Intermediate frequency

87.5 108.0 MHz

(50 kHz step)
FM lead antenna
75 ohms unbalanced
10.7 MHz

530 1,710 kHz

(with the tuning interval
set at 10 kHz)
531 1,710 kHz
(with the tuning interval
set at 9 kHz)
530 1,710 kHz
(with the tuning interval
set at 10 kHz)
531 1,602 kHz
(with the tuning interval
set at 9 kHz)
AM loop antenna
External antenna terminal
450 kHz

Tuner section
FM stereo, FM/AM superheterodyne tuner

Sony Corporation
Personal Audio Division
Published by Sony Techno Create Corporation

Continued on next page

COMPACT DISC DECK RECEIVER

CX-JDS22/JDS33

MODEL IDENTIFICATION
BACK PANEL

General
Power requirements
Mexican model:
Other models:

Power consumption
JDS33:
JDS22:

127 V AC, 60 Hz
120 V, 220 230 V or
240 V AC, 50/60 Hz
Adjustable with voltage
selector

Part No.

245 watts
198 watts

Dimensions (w/h/d) (excl. speakers):

Approx. 230 365.5
409 mm
Mass (excl. speakers)
Approx. 9.1 kg
3
#

Design and specifications are subject to change

without notice.

#
3

Model
E51 model (JDS33)
MX model (JDS33)
E51 model (JDS22)
MX model (JDS22)

Part No.
2-675-711-0[]
2-675-712-0[]
2-675-714-0[]
2-675-715-0[]

Abbreviation
E51
: Chilean and Peruvian models
MX
: Mexican model

UNLEADED SOLDER
Boards requiring use of unleaded solder are printed with the leadfree mark (LF) indicating the solder contains no lead.
(Caution: Some printed circuit boards may not come printed with
the lead free mark due to their particular size)
: LEAD FREE MARK
Unleaded solder has the following characteristics.
Unleaded solder melts at a temperature about 40 C higher
than ordinary solder.
Ordinary soldering irons can be used but the iron tip has to be
applied to the solder joint for a slightly longer time.
Soldering irons using a temperature regulator should be set to
about 350 C.
Caution: The printed pattern (copper foil) may peel away if
the heated tip is applied for too long, so be careful!
Strong viscosity
Unleaded solder is more viscou-s (sticky, less prone to flow)
than ordinary solder so use caution not to let solder bridges
occur such as on IC pins, etc.
Usable with ordinary solder
It is best to use only unleaded solder but unleaded solder may
also be added to ordinary solder.

SAFETY-RELATED COMPONENT WARNING!!

COMPONENTS IDENTIFIED BY MARK 0 OR DOTTED LINE
WITH MARK 0 ON THE SCHEMATIC DIAGRAMS AND IN
THE PARTS LIST ARE CRITICAL TO SAFE OPERATION.
REPLACE THESE COMPONENTS WITH SONY PARTS WHOSE
PART NUMBERS APPEAR AS SHOWN IN THIS MANUAL OR
IN SUPPLEMENTS PUBLISHED BY SONY.

CX-JDS22/JDS33

TABLE OF CONTENTS

The release method of a CD disc tray LOCK function

There is a disc lock function for the disc theft prevention for a
demonstration at a shop front in this machine.
Procedue:
1. Press the ?/1 button to turn the set on.
2. Set the FUNCTION to CD.
3. Insert a disc.
4. Press two buttons x and Z for five seconds.
5. The message LOCKED is displayed and the tray is
locked. (Even if exiting from this mode, the tray is still
locked.)
6. Press two buttons x and Z for five seconds again.
7. The message UNLOCKED is displayed and the tray is
unlocked.
8. To exit from this mode, press the ?/1 button to turn the
set off.

NOTES ON HANDLING THE OPTICAL PICK-UP

BLOCK OR BASE UNIT
The laser diode in the optical pick-up block may suffer electrostatic
break-down because of the potential difference generated by the
charged electrostatic load, etc. on clothing and the human body.
During repair, pay attention to electrostatic break-down and also
use the procedure in the printed matter which is included in the
repair parts.
The flexible board is easily damaged and should be handled with
care.
NOTES ON LASER DIODE EMISSION CHECK
The laser beam on this model is concentrated so as to be focused on
the disc reflective surface by the objective lens in the optical pickup block. Therefore, when checking the laser diode emission,
observe from more than 30 cm away from the objective lens.
This appliance is classified as a CLASS 1 LASER product.
The CLASS 1 LASER PRODUCT MARKING is located on the
exterior.

Laser component in this product is capable of emitting radiation

exceeding the limit for Class 1.
CAUTION
Use of controls or adjustments or performance of procedures
other than those specified herein may result in hazardous radiation
exposure.
Notes on chip component replacement
Never reuse a disconnected chip component.
Notice that the minus side of a tantalum capacitor may be
damaged by heat.

1.

GENERAL ................................................................... 4

2.

DISASSEMBLY

2-1.
2-2.
2-3.
2-4.
2-5.
2-6.
2-7.
2-8.
2-9.
2-10.
2-11.
2-12.
2-13.
2-14.
2-15.

Disassembly Flow ...........................................................

Top Panel, Side Panel ......................................................
Front Section ...................................................................
CD Mechanism Section ...................................................
Cassette Mechanism Deck, PAI/HP/MIC Board .............
PANEL Board ..................................................................
Rear Cabinet ....................................................................
Power Board ....................................................................
MAIN Board, AMP Board ..............................................
Holder (CD Mechanism) .................................................
Base Unit (BU-F1BD81AA) ...........................................
BD Board, Optical Pick-up (KSM-215DCP/C2NP) .......
Frame, Cover CD .............................................................
Belt ..................................................................................
Cassette Panel ..................................................................

3.

TEST MODE ............................................................... 15

4.

MECHANICAL ADJUSTMENTS ......................... 16

5.

ELECTRICAL ADJUSTMENTS .......................... 16

6.

DIAGRAMS

6-1.
6-2.
6-3.
6-4.
6-5.
6-6.
6-7.
6-8.
6-9.
6-10.
6-11.
6-12.
6-13.
6-14.
6-15.
6-16.
6-17.

Block Diagram BD Section ......................................

Block Diagram MAIN Section .................................
Printed Wiring Board BD Board ..............................
Schematic Diagram BD Board ................................
Printed Wiring Board MAIN Board .........................
Schematic Diagram MAIN Board (1/3) ..................
Schematic Diagram MAIN Board (2/3) ..................
Schematic Diagram MAIN Board (3/3) ..................
Printed Wiring Board PANEL Section .....................
Schematic Diagram PANEL Section (1/2) ..............
Schematic Diagram PANEL Section (2/2) ..............
Printed Wiring Board FRONT BLOCK Section ......
Schematic Diagram FRONT BLOCK Section .........
Printed Wiring Board AMP Board ...........................
Schematic Diagram AMP Board ..............................
Printed Wiring Board POWER Board ......................
Schematic Diagram POWER Board .........................

6
7
7
8
8
9
9
10
10
11
11
12
12
13
14

22
23
24
25
26
27
28
29
30
31
32
33
34
35
36
37
38

7.

EXPLODED VIEWS

7-1.
7-2.
7-3.
7-4.
7-5.
7-6.

Overall Section ................................................................

Front Section-1 ................................................................
Front Section-2 ................................................................
Chassis Section ................................................................
CD Mechanism Section-1 ...............................................
CD Mechanism Section-2 ...............................................

8.

ELECTRICAL PARTS LIST .................................. 52

46
47
48
49
50
51

Flexible Circuit Board Repairing

Keep the temperature of the soldering iron around 270 C
during repairing.
Do not touch the soldering iron on the same conductor of the
circuit board (within 3 times).
Be careful not to apply force on the conductor when soldering
or unsoldering.

CX-JDS22/JDS33
SECTION 1
GENERAL

This section is extracted

from instruction manual.

List of button locations and reference pages

How to use this page

Illustration number
r

Use this page to find the location of buttons and other

parts of the system that are mentioned in the text.

TUNER/BAND wh (14, 15)

R
Name of button/part

R
Reference page

Main unit
ALPHABETICAL ORDER

BUTTON DESCRIPTIONS

AN

MZ

AUDIO IN jack w; (28)

BASS control qf (21)
CANCEL wl (11)
CD SYNC wk (18)
Cassette compartment qh (17)
DISC 1 3 4 (10)
DISC SKIP/EX-CHANGE 5
(10, 13, 18)
Disc tray 6 (9)
DISPLAY qd (16, 25, 26)
Display window 3
ENTER wf (11, 13, 14)
EQ 0 (20)
FM MODE wd (16)
FUNCTION wj (9, 13, 14, 15, 17,
18, 19, 21, 28)
i-Bass 9 (20, 31)

MIC jack qj (21)

MIC LEVEL qk (21)
MIDDLE control qs (21)
Jog dial ws (11, 13)
PHONES jack ql
PLAY MODE wg (10, 13, 17)
REC PAUSE/START 8 (18, 19,
21)
Remote sensor 2
REP wd (12)
TREBLE control qa (21)
TUNER/BAND wh (14, 15)
TUNING +/ wl (14, 15)
TUNING MODE wg (14, 15)
VOLUME control wa (27)

?/1 (power) 1 (7, 15)

Z (eject) 7 (9)
Z PUSH (eject) qg (17)
lm/ML (rewind/fast
forward, go back/go forward)
wl (10, 17)
x (stop) wl (10, 17, 18, 21, 27,
31)
N1) or nN2) (play) wl (10,
17, 18)
X (pause) wl (10, 17, 31)
1)
2)

DBX-DS22
DBX-DS33

1 2 3 4 567

wl
wk
wj
wh
wg
wf
wd
ws
wa
w;
ql

8
9
0
qa
qs
qd
qf
qg
qh
qj
qk

CX-JDS22/JDS33

Remote control
ALPHABETICAL ORDER

BUTTON DESCRIPTIONS

AE

FZ

CD qk (9, 12)
CLEAR qg (13)
CLOCK/TIMER SELECT 2
(24, 25)
CLOCK/TIMER SET 3 (8, 23,
24)
DISC SKIP q; (10, 12)
DISPLAY wa (16, 25, 26)
ENTER 9 (8, 12, 14, 23, 24)
EQ qf (20)

FM MODE 4 (16)
FOLDER + qa (10, 12, 18)
FOLDER qd (10, 12, 18)
FUNCTION 6 (9, 12, 14, 15, 17,
28)
PLAY MODE w; (10, 12, 17)
REPEAT 4 (12)
SLEEP ws (23)
TAPE qj (17)
TUNER/BAND 5 (14, 15)
TUNER MEMORY ql (14)
TUNING MODE w; (14, 15)
VOLUME +/ qs (23)

ws
wa
w;
ql
qk
qj
qh

?/1 (power) 1 (7, 24)

m/M (rewind/fast forward)
7 (10, 17)
N (play) 8 (10, 17)
X (pause) 8 (10, 17)
x (stop) 8 (10, 17)
+/ (tuning) qh (14)
./> (go back/go forward)
qh (8, 10, 23)

1
2
3
4
5
6
7
8

qg

qf

q;

qd

qa
qs

Setting the clock

Use buttons on the remote for the operation.

1
2
3
4
5
6

Press ?/1 to turn on the system.

Press CLOCK/TIMER SET.
Press . or > repeatedly to set the
hour.
Press ENTER.
Press . or > repeatedly to set the
minute.
Press ENTER.

The clock starts working.

To adjust the clock

1
2

Press CLOCK/TIMER SET.

Do the same procedures as step 3 to 6

above.

Press . or > repeatedly to select

CLOCK SET, then press ENTER.

Notes

The clock settings are canceled when you disconnect

the power cord or if a power failure occurs.
You cannot set the clock in Power Saving Mode
(page 25).

CX-JDS22/JDS33
SECTION 2
DISASSEMBLY
2-1. DISASSEMBLY FLOW
This set can be disassembled in the order shown below.

SET

2-2. TOP PANEL, SIDE PANEL

(Page 7)

2-15. CASSETTE PANEL

(Page 14)

2-3. FRONT SECTION

(Page 7)

2-4. CD MECHANISM SECTION

(Page 8)

2-6. PANEL BOARD

(Page 9)

2-5. CASSETTE MECHANISM DECK,

PAI/HP/MIC BOARD
(Page 8)

2-10. HOLDER
(CD MECHANISM)
(Page 11)

2-7. REAR CABINET

(Page 9)

2-8. POWER BOARD

(Page 10)

2-9. MAIN BOARD,

AMP BOARD
(Page 10)

2-11. BASE UNIT (BU-F1BD81AA)

(Page 11)

2-12. BD BOARD, OPTICAL PICK-UP

(KSM-215DCP/C2NP)
(Page 12)

2-13. FRAME, COVER CD

(Page 12)

2-14. BELT
(Page 13)

CX-JDS22/JDS33

Note: Follow the disassembly procedure in the numerical order given.

2-2. TOP PANEL, SIDE PANEL

6 left panel

5 two screws
(+BVTP)(B3)

qa top panel

q;
7 two screws
(+BVTP)(B3)

4 four screws
(Case 3)

3 right panel

2 two screws
(+BVTP)(B3)

1 four screws
(Case 3)

2-3. FRONT SECTION

2 wire (flat type)

(13core) (CN604)
5 wire (flat type)
(31core) (CN101)
7 screw
(+BVTP)(B3)

3 connector (7p)
q; screw
(+BVTP)(B3)

8 screw
(+KTP 3 6)

4 wire (flat type)

(27core) (CN605)

9 screw
(+BVTP)(B3)
1 wire (flat type)
(11core) (CN112)
6 three screws
(+BVTP)(B3)

qa front section

CX-JDS22/JDS33

2-4. CD MECHANISM SECTION

1 Remove the soldering.

5 CD mechanism section

4 two screws
(+BVTP)(B3)

2 screw
(+BVTP)(B3)

3 earth wire

2-5. CASSETTE MECHANISM DECK, PAI/HP/MIC BOARD

1 wire (flat type)

(7core)
3 cassette mechanism deck
4 knob (MIC)

7 holder
(PWB MIC)

2 four screws
(+BVTP)(B2.6)

5 two screws
(+BVTP)(B2.6)
8 PAI/HP/MIC board

6 two screws
(+BVTP)(B2.6)

CX-JDS22/JDS33

2-6. PANEL BOARD

1 knob (RTRY)

3 knob (RTRY AMS)

4 screw
9 PANEL board
2 guide (LED VOL)

8 wire (flat type)

(31 core)

6 fourteen screws
(+PTP)(B2.6)

7 connector
(11p) (CN651)
5 two screws

2-7. REAR CABINET

4 rear cabinet

2 wire (flat type)

(11core)

1 connector
(2p) (CN871)

3 four screws
(+BVTP)(B3)

CX-JDS22/JDS33

2-8. POWER BOARD

1 four screws

3 POWER board

2 cord bushing

2-9. MAIN BOARD, AMP BOARD

3 screw
4 connector
(CN171)
5 MAIN board

6 AMP board

2 two screws
(+BVTP)(B3)

10

1 two screws
(+BVTP)(B3)

CX-JDS22/JDS33

2-10. HOLDER (CD MECHANISM)

6 CONTACT board
1 four screws (+BVTP 2.6 8)

5 screw (+BVTP 3 8)
3 tape

7 holder (CD MECHANISM)

2 wire (flat type)

(27 core) (CN606)
4 wire (flat type)
(16 core)

2-11. BASE UNIT (BU-F1BD81AA)

5 wire (flat type)
(27 core)

3 two floating screws

(+PTPWH M2.6)
4 two coil springs
(insulator)

1 two floating screws

(+PTPWH M2.6)
2 two coil springs
(insulator)
6 base unit
(BU-F1BD81AA)

7 tray panel

11

CX-JDS22/JDS33

2-12. BD BOARD, OPTICAL PICK-UP (KSM-215DCP/C2NP)

1 screw (+BVTP 2.6 8)

2 gap tube

5 BD board
4 Remove the four solderings of motor.
3 wire (flat type)
(16 core)
7 two insulators

6 two insulators

8 optical pick-up
(KSM-215DCP/C2NP)

2-13. FRAME, COVER CD

5 cover CD

3 two screws
(+BVTP)(B2.6)
4 earth wire

2 earth wire
6 four screws
1 two screws
(+BVTP)(B2.6)

7 frame

12

CX-JDS22/JDS33

2-14. BELT

2 Slide the upper-most tray forward the front.

1 Release the hook of the tray.

4 two belts

3 While pushing up the plate cam,

draw the Drawer (three trays) entirely forward front.

plate cam

13

CX-JDS22/JDS33

2-15. CASSETTE PANEL

3 two claws
2
1

4 cassette panel

14

CX-JDS22/JDS33
SECTION 3
TEST MODE
[COLD RESET]
* The cold reset clears all data including preset data stored in
the RAM to initial conditions. Execute this mode when
returning the set to the customer.
Procedure:
1. Press the ?/1 button to turn the set on.
2. Press three buttons x , X and [i-Bass] simultaneously.
3. The fluorescent indicator tube does not display any message
and the set is reset.
[Version Display Mode]
* The version of the microcomputer is displayed.
Procedure:
1. Press the ?/1 button to turn the set on.
2. To enter the test mode, press three buttons x , [DISPLAY]
and ?/1 simultaneously. The model name and destination
are displayed.
3. Press the [DISPLAY] button, the version is displayed.
4. To exit from this mode, press three buttons x , [DISPLAY]
and ?/1 simultaneously.
[PANEL Test]
* All fluorescent segments are tested.
Procedure:
1. Press the ?/1 button to turn the set on.
2. Press three buttons x , [DISPLAY] and [DISC 3] simultaneously.
3. Then all segments of the florescent indicator tube are turned
on.
[KEY Test]
* Keyboard check
Procedure:
1. When the panel test mode is activated. Press x and [DISC 1]
buttons simultaneously, and the key check mode is activated.
2. The message KEY 0 0 0 is displayed.
3. Press x , and [DISC 1] buttons simultaneously, and the key
count mode is activated.
4. The message KEYCNT 0 is displayed.
Each time a button is pressed, KEYCNT 0 value increased.
However, once a button is pressed, it is no longer take into
account.
5. To exit from this mode, pull out the AC plug.
[CD Ship (LOCK) & COLD RESET MODE]
Procedure:
1. Press the ?/1 button to turn the set on.
2. Select the FUNCTION to CD.
3. Press three buttons x , [i-Bass] and [DISC 3] simultaneously.
4. The RESET display blinks instantaneously and CD ship
mode is set.
5. The Cold Reset Mode is set.

[Disc Tray Lock]

The disc tray lock function for the antitheft of an demonstration
disc in the store is equipped.
Setting Procedure :
1. Press the ?/1 button to turn the set on.
2. Select the FUNCTION to CD.
3. Insert a disc.
4. Press two buttons x and Z for five seconds.
5. The message LOCKED is displayed and the tray is locked.
Releasing Procedure :
1. Press two buttons x and Z for five seconds again.
2. The message UNLOCKED is displayed and the tray is
unlocked.
3. To exit from this mode, press the ?/1 button.
Note : When LOCKED is displayed, the tray lock is not released by
turning power on/off with the ?/1 button.

[Common Test]
* This mode is used to check the function of the amplifier.
Procedure:
1. Press the ?/1 button to turn the set on.
2. Press three buttons x , [REC PAUSE/START] and [i-Bass]
simultaneously.
3. The message COMMON is displayed, when the [VOLUME]
knob is rotated clockwise. The message VOL MAX
is displayed, when the [VOLUME] knob is rotated
counterclockwise.
4. Each time the [BASS] , [TREBLE] and [MIDDLE] knob is turned,
the message EQ MAX, EQ MIN or EQ FLAT is
displayed in this order.
5. To exit from this mode, press the ?/1 button.
[AM Channel Step 9 kHz/10kHz Selection Mode]
* Either the 9 kHz step or 10 kHz step can be selected for the
AM channel step.
Procedure:
1. Set the FUNCTION to AM.
2. Press the ?/1 button to turn the set off.
3. While depressing the [PLAY MODE/TUNING MODE] button,
press the ?/1 button.
4. The channel step is changed over.
[CD Repeat 5 Times Limit Release Mode]
Procedure:
1. Press the ?/1 button to turn the set on.
2. Select the FUNCTION to CD.
3. Press three buttons x , [DISPLAY] and [DISC 1] simultaneously.
4. The repeat all mark blinks and then repeat 5 times limit is
released.
5. To exit from this mode, press the ?/1 button.

[CD Ship Mode]

* This mode moves the optical pick-up to the position durable
to vibration. Use this mode when returning the set to the
customer after repair.
Procedure:
1. Press the ?/1 button to turn the set on.
2. Set the FUNCTION to CD.
3. Press three buttons x , ML and [DISPLAY] simultaneously for more than two seconds.
4. After a message LOCK is displayed on the fluorescent
indicator tube, the CD ship mode is set and the power is turned
off.

15

CX-JDS22/JDS33
SECTION 4
MECHANICAL ADJUSTMENTS
TAPE MECHANISM DECK SECTION
Precaution
1. Clean the following parts with a denatured alcohol-moistened
swab:
record/playback heads
pinch rollers
erase head
rubber belts
capstan
idlers
2. Demagnetize the record/playback head with a head demagnetizer.
3. Do not use a magnetized screwdriver for the adjustments.
4. After the adjustments, apply suitable locking compound to
the parts adjusted.
5. The adjustments should be performed with the rated power
supply voltage unless otherwise noted.
Torque Measurement
Mode
FWD
FWD
back tension

Torque meter
CQ-102C

CQ-102C

REV

CQ-102RC

REV
back tension

CQ-102RC

FF/REW

CQ-201B

FWD tension

CQ-403A

REV tension

CQ-403R

Meter reading
2.94 7.84 mN m
(30 to 79 g cm)
(0.42 1.11 oz inch)
0.15 0.59 mN m
(2 to 6 g cm)
(0.03 0.08 oz inch)
2.94 7.84 mN m
(30 to 79 g cm)
(0.42 1.11 oz inch)
0.15 0.59 mN m
(2 to 6 g cm)
(0.03 0.08 oz inch)
6.86 17.64 mN m
(70 to 179 g cm)
(0.98 2.49 oz inch)
0.98 mN m or more
(10 cm or more)
(0.14 oz inch or more)
0.98 mN m or more
(10 cm or more)
(0.14 oz inch or more)

SECTION 5
ELECTRICAL ADJUSTMENTS
DECK SECTION

0 dB=0.775V

Precaution
1. Demagnetize the record/playback head with a head
demagnetizer.
2. Do not use a magnetized screwdriver for the adjustments.
3. After the adjustments, apply suitable locking compound to
the parts adjusted.
4. The adjustments should be performed with the rated power
supply voltage unless otherwise noted.
5. The adjustments should be performed in the order given in
this service manual. (As a general rule, playback circuit
adjustment should be completed before performing recording
circuit adjustment.)
6. The adjustments should be performed for both L-CH and RCH.
7. Switches and controls should be set as follows unless otherwise
specified.
Test Tape
Tape

Signal

Used for

P-4-A100

10 kHz, 10 dB

Azimuth Adjustment

WS-48B

3 kHz, 0 dB

Tape Speed Check

Record/Playback Head Azimuth Adjustment

Procedure:
1. Mode : Playback
test tape
P-4-A100
(10 kHz, 10 dB)

MAIN board
SPEAKER terminal (J171)
L-CH, R-CH
level meter
set

2. Turn the adjustment screw and check output peaks. If the peaks
do not match for L-CH and R-CH, turn the adjustment screw
so that outputs match within 1 dB of peak.

within
1dB

L-CH
peak

within
1dB

Output
level

Screw
position

16

R-CH
peak
L-CH
peak

R-CH
peak

Screw
position

CX-JDS22/JDS33

3. Mode: Playback

MAIN board
SPEAKER terminal (J171)
L-CH
oscilloscope

test tape
P-4-A100
(10 kHz, 10 dB)
L-CH

set

Record Bias Adjustment

Procedure:
1. Record mode

AF OSC
R-CH

PAI/HP/MIC board
AUDIO IN (J552)
1) 315 Hz
50 mV (23.8 dB)
2) 10 kHz
attenuator

R-CH

blank tape
CN-123

600
set

waveform of oscilloscope

in phase 45
good

90 135 180
wrong

4. After the adjustments, apply suitable locking compound to

the parts adjusted.

2. Mode: Playback
i-Bass OFF
BASS 0
TREBLE 0
recorded
portion

level meter

Adjustment Location: Record/Playback/Erase Head

set

MAIN board speaker terminal (J171)

3. Confirm playback the signal recorded in step 1 become

adjustment level as follows.
Adjustment level: Playback output of 315 Hz to playback output
of 10 kHz: 2 3.0 dB (0 4.5mV).

adjustment screw
Note: Refer to 2-15. Cassette Panel (see page 14)

Tape Speed Check

Mode: Playback
test tape
WS-48B
(3 kHz, 0 dB)

frequency counter
set

MAIN board
SPEAKER terminal (J171)
L-CH, R-CH

1. Insert the WS-48B into deck.

2. Press the N (JDS22) ( nN (JDS33)) button of deck.
3. Confirm that the frequency counter reads 3000 90 Hz.
Sample Value of Wow and flutter: 0.3% or less W.RMS (JIS)
(WS-48B)

17

CX-JDS22/JDS33

RFDC signal waveform

CD SECTION

VOLT/DIV: 200 mV
TIME/DIV: 500 ns

Note:

1. Use YEDS-18 disc (3-702-101-01) unless otherwise indicated.

2. Use an oscilloscope with more than 10M impedance.
3. Clean the object lens by an applicator with neutral detergent
when the signal level is low than specified value with the
following checks.

level: 0.6 0.15 Vp-p

S-curve Check
Connection:
Checking Location: BD board (Side B)(See page 19)

oscilloscope
BD board
TP (FEO)
TP (VC)

RFAC Level Check

Connection:

oscilloscope

Procedure:
1. Connect an oscilloscope to test point TP (FEO) and TP (VC)
on the BD board.
2. Set the FUNCTION to CD.
3. While depressing the N (JDS22) ( nN (JDS33)) button,
insert an AC plug.
4. Put the disc (YEDS-18) in and press the x button and actuate
the focus search. (actuate the focus search when disc table is
moving in and out)
5. Check the oscilloscope waveform (S-curve) is symmetrical
between A and B. And confirm peak to peak level within 2 1
Vp-p.
S-curve waveform
symmetry

BD board
TP (RFACO)
TP (VC)

Procedure:
1. Connect an oscilloscope to test point TP (RFACO) and TP
(VC) on the BD board.
2. Turn the power on.
3. Put the disc (YEDS-18) in to playback the number five track.
4. Confirm that oscilloscope waveform is clear and check RFAC
signal level is correct or not.
Note: A clear RFAC signal waveform means that the shape can
be clearly distinguished at the center of the waveform.

RFAC signal waveform

VOLT/DIV: 200 mV
TIME/DIV: 500 ns

A
within 2 1 Vp-p
B
Note: Try to measure several times to make sure than the ratio of A : B
or B : A is more than 10 : 7.
Take sweep time as long as possible and light up the
brightness to obtain best waveform.

Checking Location: BD board (Side B)(See page 19)

RFDC Level Check
Connection:
oscilloscope
BD board
TP (RFDCO)
TP (VC)

Procedure:
1. Connect an oscilloscope to test point (RFDCO) and TP (VC)
on the BD board.
2. Turn the power on.
3. Put the disc (YEDS-18) in to playback the number five track.
4. Confirm that oscilloscope waveform is clear and check RFDC
signal level is correct or not.
Note: A clear RFDC signal waveform means that the shape can
be clearly distinguished at the center of the waveform.

18

level: 1.0 0.4 Vp-p

Checking Location: BD board (Side B)(See page 19)

CX-JDS22/JDS33

E-F Balance Adjustment

Connection:

Checking Location:
BD BOARD (Side B)

oscilloscope
BD board
TP (TEO)
TP (VC)

Procedure:
1. Connect an oscilloscpe to test point TP (TEO) and TP (VC)
on the BD board.
2. Set the FUNCTION to CD.
1)
2)
3. AC is put in pushing N or nN button to enter the
CD test mode.
4. Put the disc (YEDS-18) in to playback the number five track.
1)
2)
5. Press the N
or nN
button. If it plays, press the
1)
2)
N or nN button again. (The tracking servo and the
sledding servo are turned OFF)
6. Check the level B of the oscilliscopes waveform and the A
(DC voltage) of the center of the Traverse waveform.
Confirm the following :
A/B x 100 = less than 10%
1) JDS22
2) JDS33
Traverse Waveform

Center of
the waveform

IC303

IC251
IC301

TP
(VC)
TP
(TEO)
TP
(FEO)

IC101

TP
(RFACO)
TP
(RFDCO)

B
A (DC
voltage)

0V

level: 1.0 0.5 Vp-p

1)

2)

7. Press the N or nN button. (The tracking servo and

sledding servo are turned ON)
8. To exit from this mode, turn the power off.
Notes: Always move the optical pick-up to most inside track when exiting
from this mode. Otherwise, a disc will not be unloaded.
Do not run the sled motor excessively, otherwise the gear can be
chipped.

Traverse Waveform

C (DC
voltage)

0V
Tracking servo
Sled servo
OFF

Tracking servo
Sled servo
ON

Checking Location: BD board (Side B)

19

CX-JDS22/JDS33
SECTION 6
DIAGRAMS
THIS NOTE IS COMMON FOR PRINTED WIRING BOARDS AND SCHEMATIC DIAGRAMS.
(In addition to this, the necessary note is printed in each block.)
For Schematic Diagrams.
Note:
All capacitors are in F unless otherwise noted. (p: pF)
50 WV or less are not indicated except for electrolytics and
tantalums.
All resistors are in and 1/4 W or less unless otherwise
specified.

f
: internal component.
C : panel designation.
Note: The components identified by mark 0 or dotted
line with mark 0 are critical for safety.
Replace only with part number specified.

20

H : adjustment for repair.

A : B+ Line.
B : B Line.
Voltages and waveforms are dc with respect to ground
under no-signal (detuned) conditions.
Voltages are taken with a VOM (Input impedance 10 M).
Voltage variations may be noted due to normal production
tolerances.
No mark: CD STOP
Waveforms are taken with a oscilloscope.
Voltage variations may be noted due to normal production
tolerances.
Circled numbers refer to waveforms.
Signal path.
F
: TUNER
J
: CD
d
: AUX
E
: PB (TAPE)
a
: REC (TAPE)
N
: MIC
Abbreviation
E51
: Chilean and Peruvian models
MX
: Mexican model

For Printed Wiring Boards.

Note:
X : parts extracted from the component side.
: Pattern from the side which enables seeing.

Caution:
Pattern face side:
(Side B)
Parts face side:
(Side A)

Parts on the pattern face side seen from

the pattern face are indicated.
Parts on the parts face side seen from
the parts face are indicated.

Indication of transistor.

C
Q

These are omitted.

B E

B C

E
These are omitted.

CX-JDS22/JDS33

Circuit Boards Location

Waveforms
BD Board

PANEL Board

IC101 ra (RFACO)

1.2 Vp-p
CONTACT board
PANEL board

VOLUME board

IC604 qd (XOUT)

62.7 ns (16 MHz)

200 mV/DIV, 1 s/DIV

1 V/DIV, 40 ns/DIV

IC101 uj (XTAO)

1.9 Vp-p

IC604 qa (XCOUT)

AMP board
59.1 ns (16.9 MHz)

1 V/DIV, 40 ns/DIV

PAI/HP/MIC board

BD board

MAIN board

POWER board

CX-JDS22/JDS33

21

21

3.1 Vp-p

30.5 s (32.768 kHz)

1 V/DIV, 20 s/DIV

1.7 Vp-p

CX-JDS22/JDS33
6-1. BLOCK DIAGRAM BD SECTION

OPTICAL PICK-UP
BLOCK
(KSM-215DCP/C2NP)
DETECTOR
VCC
VC

IC301
DIGITAL SIGNAL
PROCESSOR

IC101
RF AMP

+1.7V
+3.3V

IC303
A

26 A

PCMD1 61

11 SDO0

VDD 55

27 B

LRCK1 62

16 LRCKIA

VDD 21

28 C

LRCK 63

19 SFSY/LRCK1B

29 D

PCMD 65

14 SDIO

19 E

BCK 66

20 F

BCK1 60

LD
DRIVER

+3.3V
IC251
SL/SP MOTOR
DRIVER
F+
F
T+

TRACKING
COIL

78 XTAI

M101
M
(SPINDLE)

DATA 102
7 SSTP
S101

XLAT 104
CLOCK 105
SENS 107

16 CH2OUT-F
CH1FIN 5

36
8
7

MICK

XRST 100

11 TFDR

SCOR 115

MP3STB
MP3REQ
MIACK

37 PD

VR

FOCUS
COIL

XTACN 95

PD

XTACN

XRST

MIDIO
MILP
MICS
MP3RST

XLAT

SCOR

CLOCK

SENS

SENS

CLOCK

SCOR

XLT
DATA
XRST

12 TRDR

XTACN

17 CH1OUT-R
CH2FIN 7

66 P26
67 P25
65 P27
28 P72/CLK2
29 P71/RXD2
68 P24
63 P30
61 P31

DATA

15 CH2OUT-R
CH1RIN 6

3.3V

18 SBSY/BCK1B

77 XTAO
X171
16.9MHz

IC604(2/2)
SYSTEM CONTROLLER

15 BCKIA

36 LD

GND

REG

VDDM 40

Q10
LD

19 P83/INT1
32 P66/RXD1
33 P65/CLK1
69 P23
31 P67/TXD1
70 P22
60 P32

13 FFDR

18 CH1OUT-F
CH2RIN 8

14 FRDR

19 CH4OUT-R
CH3FIN 30

9 SFDR

20 CH4OUT-F
CH3RIN 29

10 SRDR

AOUT1 81

6 MDP

AOUT2 86

LOUT

21 CH3OUT-F
M102
(SLED)

OPIN+ 3

ROUT

MAIN
SECTION
(Page 23)

22 CH3OUT-R
MUTE 24

R-CH is omitted due to same as L-CH.

Signal Path
: CD

CX-JDS22/JDS33

22

22

CX-JDS22/JDS33
6-2. BLOCK DIAGRAM MAIN SECTION
IC301
POWER AMP
+VH

8 +VCC

-VH

1 -VCC

3 +VP

2 -VP

SELECTOR
IC401

R-CH

11 LI+

OUT-L 28

31 AUX-L

OUT-R 27

33 B1

LO+ 4

ST-BY

J552
AUDIO IN

R-CH

R-CH

Q301
OVERLOAD
DET

2 PBIP
35 C1

TUNER PACK

RY171

40 REC10

+9V

R-CH
Q401,403

+Vcc

8 VOL1

L-CH

43 P53

P60/CTS0 38

18 SD

CLK

42 P54

P57/CLKOUT 39

19 SC

CE

40 P56

TUNED

26 P74

DO
DI

STEREO

27 P73/CT52

TU-MUTE

23 P77

BB1 26
BB1 25

9 VOL2

SYSTEM CONTROLLER
IC604 (1/2)

R-CH

R-CH

BB2 24
BB2 23

J171
SPEAKER

TH361

BASS-AGC
CONTROL

R-CH
R
Q362
THERMAL
DET

Q301 - 306
MUTE
CONTROL

Q502-504

L-CH

REC/PB
SWITCH

R-CH

L501
BIAS OSC

Q151-153
P01/AN01 87

BIAS
OSC

P61/CLK0 37
-VFL

BIAS
SWITCH

P16/INT4 74

VM
(+10V)

+3.3V

3CD MECHA

59 P33

I CD_CSW1

58 P34

SW7 (CHACK)

57 P35

I CD_CSW2

56 P36

SW6 (CLOSE)

55 P37

SW5 (STOC)

54 P40

SW8 (OPEN)

53 P41

FUNCTION
KEY

P106/AN6 90

FUNCTION
KEY

P105/AN5 91

FUNCTION
KEY

P101/AN1 95

RTRY
AMS

P100/AN0 97

RTRY
VOLUME

D155

S652
51 P43

Q623,624
48 P46

P51 45

D157

D152

Q614

MOTOR
DRIVE

D153

LED607
STAND BY

LED
CONTROL

D154

Q621,622
M2

MOTOR
DRIVE

49 P45
Q613

10 XC IN
X601
32.768kHz

P42 52
11 XC OUT

L OUT
R OUT

D156

S651

MOTOR
DRIVE

: MIC

FAN CURENT
DETECT

S601-609

Q627,628

M2 M

Q874

S621-629

50 P44

MOTOR
DRIVE

+M2

: PB (TAPE)
: REC (TAPE)

P107/AN7 89

Q629,631

M1

: AUX
FL601
LCD

S611-619

24 P76

M1 M

VM

D155

I CD_CSW3

+M1

PROTECT
DET

SEG1 14
7 DINVLCD
29
8 CLK SEG19 31
9 STB
33
30 VEE GR1
42
13 VDD
GR9
34
43 VDD

P63/TXD0 35

: TUNER

M871
FAN

FAN
DRIVE

R-CH

: CD

IC601
LCD DRIVER

P62/RXD0 36

Q507-510

ERASE
HEAD

D158

+VL

25 P75

Q871-873

D871 D872

Q501

Q505,506

Signal Path

AMP
CONTROL

P80 22

DECK BLOCK

R-CH is omitted due to same as L-CH.

Q366,367
AMP
PROTECT

Q361

REC/PB
HEAD R-CH

J551
PHONES

LO- 5

13

R-CH

BD SECTION
(Page 22)

X602
16MHz

Q619,620,625,626,632

LED608
i-BASS

LED
CONTROL

15 X IN
D101
13 X OUT

CD
MOTOR
CONTROL

+VH

Q608-610,615-617
47 P47

P02/AN02 86
P07/AN07 81

LED
DRIVE

LED601-606
-VH
D102

DC 7V

PT001 (MX)
PT002 (E51)
POWER TRANSFORMER

+VL
Q618, Q630
J553
MIC 1

LED
CONTROL

P00/AN00 88

IC551
MIC AMP

VM (+10V)

FL1

-VL

VR501

VM
(+10V)
MODEL

1
7

SUFFIX

92 P104/AN4

TU9V

93 P103/AN2

CD 7V

Q551,552

J554

FL2

IC101

Q801,803

10V
REG

1
D115

+9V
REG

D119-117,214

MIC
OVERLOAD
DET

D111

IC102

D VDD(3.3V)

MIC 2

3.3V
REG

A VDD(3.3V)

Q101
D116

-VFL
(-27V)

Q102

D112

-27V
REG

RY002

RELAY
DRIVE

E51

MP3VD
P81 21
75 P15/INT3

D141
IC602

JDS22

D602

4 +3.3V
REG

S001
VOLTAGE
SELECTOR

V STBY

JDS33

PLAY

2 P95

R REC

3 P94
4 P93

F REC
PACK

5 P92

END
Q607,611

DECK M
MOTOR

REMOTE
1 CONTROL 3
RECEIVER

P90 7

MECHA BLOCK

D001,002

IC605

PT003 (MX)
PT004 (E51)
TRANSFORMER (SUB)

MOTOR
DRIVE

D003

Q605
P82/INT12 20

94 P102/AN2
RES 12
100 P97

AC IN

uCON +B

MX

SWITCH
Q606
RESET
SWITCH

IC603
3

RESET

D604
1

Q604,612
T SOL
DRIVE

1 P96

6 P91

CX-JDS22/JDS33

23

23

CX-JDS22/JDS33
6-3. PRINTED WIRING BOARD BD BOARD

See page 21 for Circuit Boards Location.

:Uses unleaded solder.

Semiconductor
Location

SPINDLE
MOTOR

IC303
3 1
4

Ref. No.

Location

IC101
IC251
IC301
IC303

E-9
C-7
C-9
B-10

Q10

F-4

(LIMIT)

IC301

IC251

17

1
64

33

48

SLED
MOTOR

TP
(VC)

TP
(TEO)

IC101

TP
(FEO)

TP
(RFDCO)
E

TP
(RFACO)

OPTICAL
PICK-UP
BLOCK
(KSM-215DCP/C2NP)

CX-JDS22/JDS33

24

24

CONTACT BOARD
CN606
(Page 33)

CX-JDS22/JDS33
6-4. SCHEMATIC DIAGRAM BD BOARD

See page 21 for Waveforms.

See page 39 to 41 for IC Block Diagrams.

CN101
16P
C15 0.1

JPO10
APC

R11
0

TP10 E
TP11 D

R13
1

TP12 A
TP13 B

Q10
2SA2119K

TP14 C
C14
0.1

C10
10

TP102 F

TP15 PD

TP121
RFDCO

TP123

C122
0.1

TP122

C123 0.1

R121 15k

C133
0.01

R10 TP424
3.3 IOP2

C124
330p

TP124 RFACO

C131 100p

R133
180k

TP423 IOP1

C16
1

C18
1000p

TP125 RFACI

C143
0.1

R141 4.7k

R151
0

C141
0.1

R132 10k

C151
100
10V

R203
0

C132
0.47

R131 1M

C134
0.1
R143
3.3k

C17
220
4V

C11 10

R12
100k

C125
0.1

R142 1k

R307
10k

TP304

C307
0.1

C142
1500p

TP17 FTP18 T-

TP302
TP303

C308
47
4V

C161 0.1
R302 10k

TP19 F-

TP427
PCMDI

R351 100

C309
0.1

TP103
LRCK

R352
100

C306
0.1

IC301
TC94A34FG-002

R303
100k

R405 100

R353 100

R404 100

R354 100

C310
0.1

TP104 PCMD

TP105 BCK

R419 100
R403 100

R111 1k
JPO102 FEI

C162
0.1

R402 100

R161 100

R401 100

C174
0.1

C320
0

C172
27p
X171
16.9MHz

C113 3300p

C115 0.1

C171
22p
R171
470

C114 470p

C116
100
10V

TP177
VC
TP428
FRDR

IC101
CXD3059AR

R172 1M

R313 C315
0.1
220
TP301
C313 0.1

R306
0

C311
0.1

C317
0.01

R112 15k
C112 470p

R114 15k
JPO103 TEI

R305 100k
C316
0.0022

C111 3300p

R113 1k

C318
0.01

R301 100k

R173 0

C314 47 4V
C185
470p

C186
470p

C305
220
4V

TP422
MP3GND

C181
0.1

C182
0.1

R251
10k

C183
22
6.3V
C184 22 6.3V
TP167
LOCK

R182 100

TRDR

TP431

TFDR

R252 C251
22k 6800p

C258
0.1
R253
10k
C259
0.1

TP432
MDP

TP178
FOK
TP166
DFCT
TP165
MIRR

C194
0.1

TP160
WDCK
TP162
COUT

R191 0

R162 47k

C163 0.1

R165
0

TP186
MVDD

R166
1k

TP145
WFCK
TP144
XUGF
TP147
XPCK
TP153
GFS
TP146
C2PO

TP425
SW+

IC251
FAN8040G3

C210
0.1

CN201
27P

FFDR

TP430

C195
0.1

R163 100

C302
0.1

IC303
BH15FB1WG

FB301
0

TP433
MP3VDD

TP429

JPO004 MDP

R181 100

C312
0.1

C303
0.1

(KSM-215DCP/C2NP)

TP16 F+

S101
IL-SW

C196
0.1

TP250
SPC257
0.1

TP187
MGND
TP426
SW-

TP436
AVDD

TP401 MP3STB

TP251
SP+

M101
SPINDLE
MOTOR

TP252 SL+

TP402 MP3REQ
TP403 MIACK
C201
100 C209
10V 0.01

TP404 MICK
TP405 MIDIO
TP406 MILP

TP420

TP407

MICS

TP408

MP3RST

TP417

SCOR

TP416

SENS

R410 100

TP415

CLK

R409 100

TP414

XLT

R408 100

TP413

DATA

R407 100

TP412

XRST

TP419

XTCN

TP434

AVDD

TP410

ROUT

TP411

LOUT

TP409

DOUT

AGND

C203
100
10V

C252
0.1
R502
0

TP421
DGND

34

R201 0

R205 0
R411 100

R406 100
R412 100
C213 22p

C212 22p

C211 220p

TP435 DVDD
R204
0

CX-JDS22/JDS33

25

25

R167
100

C260
220
10V

C255
0.1

TP253
SL-

M102
SLED
MOTOR

CX-JDS22/JDS33
See page 21 for Circuit Boards Location.

6-5. PRINTED WIRING BOARD MAIN BOARD

:Uses unleaded solder.

LCH
-

REC/PB
RCH

+
-

FAN

ERASE
+
1

TU803

HEAD
(REC/PB/ERASE)

TUNER PACK
E

11

IC401

FFC802

C
E

E
4

6
8

7
S
K/A
E

E
A

3
E

E
E

AMP BOARD
CN301
(Page 35)

K
A

D
PAI/HP/MIC BOARD
FFC552
(Page 33)
A
K

PANEL BOARD
CN601
(Page 30)

Semiconductor
Location
Ref. No.

Location

D101
D103
D104
D105
D106
D111
D112
D113
D114
D115
D116
D117
D118
D119
D120
D124
D141
D152
D153
D154
D155
D156
D157
D158
D401
D402
D502
D801
D871
D872

F-5
F-5
F-5
F-6
F-5
E-5
E-5
E-6
E-6
D-6
D-6
C-8
B-8
B-8
D-2
C-8
D-5
E-5
E-5
E-5
E-5
E-5
E-5
D-5
B-4
B-4
B-6
C-3
F-2
D-5

IC101
IC102
IC401

E-4
E-4
B-5

Q101
Q102
Q151
Q152
Q153
Q401
Q403
Q501
Q502
Q503
Q504
Q505
Q506
Q507
Q508
Q509
Q510
Q801
Q803
Q871
Q872
Q873
Q874

D-6
D-6
D-5
D-5
D-6
B-5
C-5
A-7
B-7
B-7
B-6
B-7
B-6
B-7
C-7
B-6
C-6
C-3
C-3
C-5
C-5
D-5
C-5

E
E

K/A
A

E
E

13

IC101

SPEAKER
(IMPEDANCE USE6)

A
A

G
POWER BOARD
WH001
(Page 37)

A
K

1
3

1
3

JDS22

POWER BOARD
WH002
(Page 37)

JDS22

IC102
K
A

A
-

D101

JDS33

15
15

1-866-477(CHASSIS)

(CHASSIS)

CX-JDS22/JDS33

26

26

CX-JDS22/JDS33
6-6. SCHEMATIC DIAGRAM MAIN BOARD (1/3)

JR801 JR
FFC802 11P
JR802 JR
R803 0
TU803
TUNER PACK

L802 0

R810 0
L801 0

R811 0

C804
0.1

R812 0
R813 0
R801 10k
R814 0

M871

CNP871
3P

R804
22k

Q801
2SA1365-T112-1EF

R873
22
1/2W

R806
1k

D801
MC2840-T112-1

C803
22
25V

R805
1k

R876
1k
R808
10k

R809
22k
R872
2.2k

CN112
11P

R871
2.2k

MIC-ON/OFF

R878
22k

D871
MC2838-T112-1

R191 1k

C116 0.01

R875
0

R807
4.7k

Q803
2SC3052EF-T1-LEF

C802
220
10V

R874
22
1/2W

JR101
0

C872
47
25V

R196 4.7k

R880
1k

Q871
2SC3052EF-T1-LEF

R877
22k

R879
470

R881
2.2k
R882
2.2

R884 22

Q874
2SC3052EF-T1-LEF

34

C180
0.1

R172
220
1/2W

C873
4.7
50V

R171
220
1/2W

R174
220
1/2W

R173
220
1/2W

R150
47
1/2W

L171

C171
0.1

C177
0.01

R138
47
1/2W

R179
10
1/2W
RY171

C173
0.1

J171

R139
47
1/2W

D120
1SS355TE-17

R181
10
1/2W

C175 0.1

* R449, R450 * R479, R480

0 : JDS33
100 : JDS33
1K : JDS22
2.2K : JDS22 R482
470P
R450
R480
*
*

(IMPEDANCE USE 6 )
C176 0.1

C178
0.01

C174 0.1
R182 10 1/2W

C172 0.1

L172

R180
10
1/2W

R449
*

EP102
EARTH,PLATE
C479
1
50V

C480
1
50V

28

CX-JDS22/JDS33

27

27

R479
*

R471
0

C853
100
16V

Q873
2SC3052EF-T1-LEF

R195 4.7k

R192 1k

Q872
KTA1266GR-AT

D872
MC2836

R481
470P

R883
220k

R885
2.2

29

CX-JDS22/JDS33
6-7. SCHEMATIC DIAGRAM MAIN BOARD (2/3)

27

CN171
13P

R154 220k

R175
47k
C152
0.01

R153 220k
D152
MC2838-T112-1
D158
MC2840-T112-1

36

R158
1k

R157
1k

R156
2.2k

R155
2.2k

R151
1k

R152
1k

R108 4.7k

R116 4.7k

R112 4.7k

R115 10k

R111 10k

R104 4.7k

R107 10k

R103 10k

R146 0

R145 0
R110 2.2k

R114 2.2k
R113 22k

C128
100p
R161
47k
R163
47k

C124
1

R160
2.2k

D157
MC2836

Q152
2SA1235TP-1EF

R162
100

C123
1

C151
100
10V

Q151
2SC3052EF-T1-LEF

D155
MC2836

D156
MC2836

C129
100p

Q153
2SC3052EF-T1-LEF

R164
100
R165
100

* R102, R106
22K : JDS33
10K : JDS22
* R143, R144
0 : JDS33
10K : JDS22
D111
10EDB40-TB5

C110
0.1

R109 22k

R144 *
R106 *

R102 *
R101 22k

R105 22k

R143 *

R159
2.2k

D153
MC2838-T112-1

D154
MC2838-T112-1

C109
0.1

D112
10EDB40-TB5

R136
470
1/2W

R133
470
1/2W

R147
470
1/2W

R148
470
1/2W

R149
*

R135
470
1/2W

R134
470
1/2W

R183
470
1/2W

R184
470
1/2W

R185
*

C111
3300
25V

HT101
10DG/W

R137
470
1/2W

R140
470
1/2W

* R149, R185
470 1/2W : JDS33
220 1/2W : JDS22

29

IC102
TA78033LS
JDS22
D104
1N5402-F46

JDS33

D103
1N5402-F46

C105
3300
71V

D141
UDZSTE-173.6B

D101
D10XB20

C101
0.1
100V

C106
3300
71V

JDS22
D105
1N5402-F46

38

WH102
7P

IC101
TA7810S
C102
0.1
100V

C118
100
16V

R129
100k
D116
MC2836

C112
22
50V

C119
47
50V

D115
UDZSTE-1727B
C113
100
50V

R117
4.7k

Q101
2SA1115TP-EF

R142
2.2k
R128
1
1/2W

C114
0.1

R118
1k

R130
22k

R131
47k

D106
1N5402-F46
D113
10EDB40-TB5

Q102
2SC3052EF-T1-LEF

R120
2.2k
R119
10

D114
10EDB40-TB5

38

R141
100k

C117
47
25V

C115
4700p

WH101
5P

EP101
EARTH,PLATE

CX-JDS22/JDS33

28

28

R132
220k

CX-JDS22/JDS33
See page 41 for IC Block Diagram.

6-8. SCHEMATIC DIAGRAM MAIN BOARD (3/3)

CN101
31P

R170
0

C120 2200 10V

C442 22p

R407
10k

C432
1000p

C453
0.1

C451
0.1

C534
220p

R501
47k

C414 0.01

R411
4.7k

R410
4.7k
C542
22p

R574
1k

C541
22p

R504
4.7k

R505 C503
10k 2200p

C403
0.22

JR401 0

C535
2200p

C504
4700p

R506
470k

C407
1000p

C408
1000p

C409
1000p

C412 C411
0.01 0.01

C410
1000p

C404
0.22

C447 470p

C448 470p

R412
4.7k

R502
220k

R509
47

R539
220k

Q502
2SK2541-T

R510
47k

Q503
2SK2541-T

R508
22

R507
2.2M

R520 100

JW102

Q501
2SA1235TP-1EF

R581
100k

C505
100
10V

R503
220k

JW244

R409
10k

C431
1000p

C406
100000p

R405
4.7k

R447
2.2k

R408
10k

C501
0.1

C413
0.01

D118 10EDB40-TB5

D117 10EDB40-TB5

R406
4.7k

R448 2.2k

C441
22p

D124 10EDB40-TB5

C405
100000p

R518 100

C512
47p

C509 47p
R573
1k

27

R511
4.7k

R512
10k

C507
4700p
C536
2200p

R513 470k
R514 2.2M
C506
2200p

C502
220p

R517
47k
R516
47

Q504
2SK2541-T

C127
0.1

D119 10EDB40-TB5

31
30
29
28
27
26
25
24
23
22
21
20
19
18
17
16
15
14
13
12
11
10
9
8
7
6
5
4
3
2
1

MIC-ON/OFF

31

C508
100 10V

R515
22

R519
47k

IC401
BD3882FV

C510
1000p

C513
1000p

R549
22k
R533
10k
C515
180p

C517
180p

R415
2.2k

R417
2.2k

C421
0.047

R429 4.7K

R427 22k
R430
4.7K

C438
470p

R433 47k
R434 47k
C435
1
50V
R419
470k

4700p

2200p

R528
1k

C518

R525
2.2k

R550
22k

C538 2200p

R524
1k

C516 4700p

C434 1000p

C433
1000p
R438
0

C437
470p
R428 22k

R531
10k

R523 22k

R440 2.2k

R416
2.2k

R527
22k

R526 2.2k

R437 0
R439
2.2k

R414
2.2k
D401
UDZSTE-174.7B

R424 4.7k

C420
0.22

C424
0.047

C402
100 10V

R423 4.7k

C423
0.22

C430 0.22

C422
0.22

C428 4.7 50V

C429 0.22

C419
0.22

50V

R413
4.7k

C427 4.7

C401
100
10V

R530
2.2k

C537

D402
UDZSTE-174.7B

C416
0.01
C415
0.01

CNP501
7P

R521
47k

R534
10k

R529
2.2k

R532
10k
JW501
C524
470p

C523
470p

R537
2.2k

R535
2.2k

R538
4.7k

R443
10k
R444
10k
R445
0
R446
R441 0
4.7k
R442
4.7k

R540
10k

R536
4.7k
Q505
2SC3052EF-T1-LEF

C525
0.1

Q506
2SC3052EF-T1-LEF

C436
1
50V

R418
470k
R582 10k
Q403
2SC3052EF-T1-LEF

R421
100k

Q509
KTA1266GR-AT

C449
C439 2.2
0.1
50V
C440

C426
4.7
50V

0.1

C425
0.01
R420
220k

Q401
UM6K1N-TN

R545
10k

C531
2200p

C526
4700p
100V

Q507
2SC2603TP-EF
Q508
2SC2603TP-EF

R548
4.7

C529
10
50V

Q510
RT1N430C-TP-1
C527
0.1

L501
85KHZ OSC BIAS

28

R121
1 1/2W

R125
220

R122
470

R124
470

R126
10k

R127
10k

CX-JDS22/JDS33

29

R547
4.7k

C539
22
25V

C533 0.1

R123
220

R542
4.7

R583
2.2k

R546
4.7

C532
2200p

R522
22

D502
1SS355TE-17

C528
0.01

C530
R544 2200p
10k

29

C521
2.2
50V

CNA501
7P

CX-JDS22/JDS33
6-9. PRINTED WIRING BOARD PANEL SECTION

See page 21 for Circuit Boards Location.

:Uses unleaded solder.

FL601
(FLUORESCENT INDICATOR TUBE)

CD
MECHANISM
DECK

Semiconductor
Location

E
E
E

IC601

IC602

E
E
E

STANDBY

DISC 3

DISC SKIP/
EX-CHANGE

DISC 1

DISC 2

Ref. No.

Location

D601
D602
D603
D604
D605
D607
D665

F-5
E-5
E-3
E-5
E-5
E-2
F-4

IC601
IC602
IC603
IC604
IC605

A-3
B-6
E-4
E-4
F-5

Q604
Q605
Q606
Q607
Q608
Q609
Q610
Q611
Q612
Q613
Q614
Q615
Q616
Q617
Q618
Q619
Q620
Q621
Q622
Q623
Q624
Q625
Q626
Q627
Q628
Q629
Q630
Q631
Q632

F-4
E-5
E-4
F-3
G-5
G-6
G-6
F-5
F-4
D-1
B-6
G-6
G-6
G-6
F-5
A-3
A-3
A-2
A-2
A-2
A-2
B-3
A-3
B-2
A-2
B-2
F-5
B-2
D-3

CANCEL
TUNING +

JDS22

TUNING

JDS33

E
i - Bass

REC PAUSE/
START

TUNER/BAND

EQ

51

CD SYNC

FUNCTION

50

31

IC604

80

30

PLAY MODE/
TUNING MODE

81

TREBLE

K
K

100

26

IC603

A/K

R609

A
1

27

R610

E 3

A
K
E

MAIN
BOARD
CN101
(page 26)

IC605

MIDDLE

E
JDS22
E
E

E
ENTER

JDS33
E

DISPLAY

(CHASSIS)

BASS

CONTACT BOARD
CN605
(page 33)

TAPE
MECHANISM
DECK

15
11

13
13

REP / FM
MODE

FOR FLASH

15

CX-JDS22/JDS33

30

30

VOLUME
BOARD
CN652
(page 33)

CX-JDS22/JDS33
See page 21 for Waveforms. See page 43 for IC Pin Function Description.

6-10. SCHEMATIC DIAGRAM PANEL SECTION (1/2)

Q619, Q620, Q625, Q626, Q632

Q626
KTA1273-Y-AT
Q612
2SA1365
-T112-1EF

R701
47k

Q627
2SA1365
T112-1EF

R676
1k

C624
4700p

JDS33

C658
0.1

C660
1000p

R645
47k

R693
100

D602
MC2836

R698
10K

C631
0.1
C606
C605 0.1
100
16V

C611 22 35V

C640
470p

R796
22k

C636
1000
6.3V
C601
1000
6.3V

C625
0.022

Q607
RT1N441C
-TP-1

C676 0.1

R708
470

R707
47k

R667
47k

R664
470

R668
470

R671
47k

Q625
2SA1235TP
-1EF

R713
10k

R716
2.2k

R632
10k

R662 1k
R659 1k

D605 1SS355TE-17

R633
22k

IC603
PST3429UL

C651
10
50V

C652
22
35V

C633
0.01

R736
100k

C609
0.047
Q606
RT1N441C
-TP-1
RESET

R663 1k

D603
MC2836

R689 1k
R651 1k

C678
0

Q605
2SC3052EF
T1-LEF

R728
2.2k
R660 1k

R737 100k

R606
10k

Q604
RT1N441C-TP-1

R691
1M

R603
220k

D604
1SS355TE-17

R703
470

CN604
13P

IC605
MM1614A

D601
UDZSTE-1710B

Q619
2SA1235
TP-1EF

R725
22k

C653 10 50V

R797 470
C642 0.1

IC602
RPM7240-H18

R612
100

R613
100

R704
47k

R673
1

R717
2.2k

Q622
2SC3440-T12-1F

C659
1000p
R646
1k

Q620
2SC3052
EF-T1-LEF
R721
470

Q624
2SC3440
-T12-1F

Q628
2SC3440-T12-1F

R644
1k

R670
470

Q631
2SC3440-T12-1F

D665
1SS355TE-17

R647
47k

R709
22k

C638
1000p

R723
10k
R611
100

C623
4700p

R672
1

R715
2.2k

Q623
2SA1365
T112-1EF

R666
470

JR607 0

C665
0.1

R724 22k

R712 22k

C670

R727 22k

R731 22k

* C670
0.1 : JDS22(MX)
0.047 : EXCEPT JDS22(MX)

C634
1000p

C600 1000p

R656
1K

R678
1k

JDS22

R706
470

R726
22k

R655 1k
JR604 0

R669
47k

Q621
2SA1365
T112-1EF

Q629
2SA1365
T112-1EF

R702
470

R654 1k

R665
47k

R705
47k

C644 0.1

Q611
2SA1365
-T112-1EF

FFC602
8P

C608 22p

X601 32768Hz
R608 10M

C637 2p

C666 1000p

X602
16MHz R601
0
C657 47p

IC604
M30302MCP
-A07FPU0
JR608
0

R690 1k

R602 100k

C607 22p

JR601
0
C677
0

Q632
2SC3052EF
-T1-LEF

C602 0.1

R696 1k

R729 10k

C622
47p

C632
47p
C618
47p
C620
47p

C664
0.1
R686 22k
R684 22k
R687 22k

R695
100k

R692
100k

CN601
31P

MIC-ON/OFF
R631 100
R630 100
R634 100

R685 22k
C619
47p
C656
47p

R682 22k
R683 22k
R661 22k

L611
BLm21A102S
R648
100

R626 2.2k
R627 2.2k

C628
47p

R625 1k
R624 470
R623 470

R722 10k

R732
10k
C643
47p

C662 47p
C663 0.1

C630 47p

R710 22k

R782 10k

CN602
27P

L603 0

L604 0
R681 1k
R720
10K

R637 100

C645 22p

R680 0
R679 1k

C646 22p
C647

R675 470

29

R622 1k

R635 1k

R621 1k

R730 1k

R620 1k
R636 10k

R619 1k

22p

C671
0.1

R618 100
R643 100

L602 BLm21A102S

C648 22p

R642 100

R617 1k

R639 100
C649 22p

R638 220

R616 1
R615 0

R640 0

R614 0

R641 10k

C674 100p

34

R629 1k
L605 0
L606 0
L607 0

CN699
9P

L608 0

L610 0

L609 0

D607
MC2840-T112-1

32

CX-JDS22/JDS33

31

31

C680
100
10V

CX-JDS22/JDS33
See page 42 for IC Block Diagram.

6-11. SCHEMATIC DIAGRAM PANEL SECTION (2/2)

31

FL601

FLDR601
FLDR-FL
C682
220p

C615
1
50V

C614
1
50V

C603 0.1

C616
22
35V

C610
220p
C635 220p
C612 220p
C613 220p
C639 220p
C654 220p

IC601
uPD16315GB-3BS

C655 220p
C661 220p
C621
220p

LED608
RED
I-BASS
SLI325-URC
R653
470

JR605
JR

R605
470k

R780
22k

R801
22k

R781
22k

R802
22k

Q630
2SA1115
TP-EF

C650
22
35V

R607
100k

R805
2.2k R806
4.7k
R804
10k
Q618
RT1N441C-TP-1

R677 1k

R657 1k

R628
100

R652
470

R776
47k

R778
22k

R786
10k

Q613
2SC3052EF-T1-LEF

Q614
2SC3052EF-T1-LEF

R650
10k

C667
100p

C669
100p

R658 1k

R649 100k

R604
100k

C668 100p

TP902

R777
22k

R803
22k

LED607
RED
STBY
SLR325-VC-N-T32

R734 1k

C604
0.1

R779
10k

R735 1k

C629
0.1

R787 R788
470 100

S621

R733
1k

R789
1k

R790
1k

S622

R791
2.2k

R792
2.2k

S624

S623

R794
10k

R793
4.7k

S626

S625

R795
22k

S627

S629

S628
PLAY MODE/
TUNING MODE

R757
470

R758
100

R759
1k

R760
1k

R761
2.2k

R763
4.7k

R762 2.2k

R764
10k

R765
22k

R609
Q608
2SC3052
EF-T1-LEF

Q616
2SC3052
EF-T1-LEF

Q617
Q615
2SC3052 2SC3052
EF-T1-LEF
EF-T1-LEF

Q609
2SC3052
EF-T1-LEF

* R609
4.7K : JDS33
10K : JDS22

Q610
2SC3052
EF-T1-LEF

S606
S602

S601

S603

S604

S607

S605

S608

S609

JDS22
JDS33

R610
10k

R739
2.2k
R766
10k

R767
470

S611

R768
100

R769
1k

R770
1k

R772
2.2k

R771
2.2k

S612

S613

S614

S615

R773
4.7k

S616

R774
10k

S617

R775
22k

R745
47k

R740
4.7k
S618

S619

R741
10k

R738
1k

R742
2.2k

34

R744
220k
S651

CN651
11P

R743
47k
EP601
EARTH,PLATE

CX-JDS22/JDS33

32

32

CX-JDS22/JDS33
6-12. PRINTED WIRING BOARD FRONT BLOCK SECTION See page 21 for Circuit Boards Location.

:Uses unleaded solder.

CONTACT BOARD

MAIN BOARD
CN112
(Page 26)

27

IC551

(CHASSIS)

26

11

FFC552

E
S

MIC LEVEL
-865-366-

(CHASSIS)

15

MIC2

15

PANEL BOARD
CN602
(Page 30)

MIC1

AUDIO IN

PHONES

VOLUME BOARD

27

11

C
A

26
10

PANEL BOARD
CN651
(Page 30)

2
1

VOLUME

1-866-932-

LED601-606
ILLUMINATION

BD BOARD
CN201
(Page 24)

15
15
15
15

CX-JDS22/JDS33

33

33

CX-JDS22/JDS33
6-13. SCHEMATIC DIAGRAM FRONT BLOCK SECTION

CN606
27P
R746 47k

S652
RTRY
VOLUME
R754
470

R798
47

R799
470

R800
470

R755
47

R756
47

R783
470

R719
470

R720
470

R718
47

R784
47

R785
47

CN605
27P

R747
4.7k

R748
10k

R749
1k

R750
2.2k

R752 47k

R751 220k
LED606
RED
VOL
SLI-325URC

LED604
RED
VOL
SLI-325URC

LED605
RED
VOL
SLI-325URC

LED603
RED
VOL
SLI-325URC

LED602
RED
VOL
SLI-325URC

LED601
RED
VOL
SLI-325URC

R753 2.2k

32
CN652
11P

25
31

R551 47 1/2W

J551

R552 47 1/2W
L551
0

R553
4.7k

J552

R554
4.7k
L552
0
R563 47k
R564
220k

C551
1
50V

C555
220p
IC551
NJM14558M-TE2

C563
0.01

VR501
50K(B)
MIC VOL
C565
0.1

C556
470p

C559
0.1
R565
2.2k

R566
4.7k

R576
22k

JR551
0

MIC-ON/OFF
27

R580
220
R572
100

R568
100k

JR552
0
C569
0.1

R555
4.7k

JR502 0

R559
100k

L553

JR503
0

Q551 2SK2541-T
C557
220
10V

C552
470p

R575
22k
R569
47k

C560
0.1
EP501
EARTH,TERMINAL

R558
2.2k

R560
2.2k

C566
0.1

C567 0.1

R557
4.7k

C553
0.22
50V

Q552
2SC3052EF
-T1-LEF
C564 0.01

R561
220k

C562
100p

C558 100 10V

R562
47k

R567 4.7k

R556
2.2k

J554

FFC552
11P

R570
470k
R571
1M

C554
0.22

C568 0.1
C561 0.1

CX-JDS22/JDS33

34

34

EP502
EARTH,TERMINAL

J553

C550
22
10V

CX-JDS22/JDS33
See page 21 for Circuit Boards Location.

6-14. PRINTED WIRING BOARD AMP BOARD

:Uses unleaded solder.

6
Semiconductor
Location

A
15

IC301

JDS22
A

K
JDS22
A

JDS22

JDS22
E

E
E

(CHASSIS)

MAIN
BOARD
CN171
(Page 26)

K
A

E
R364

E
E
13

15
1-866-479-

CX-JDS22/JDS33

35

35

15

Ref. No.

Location

D361
D362
D363

A-5
A-5
C-5

IC301

A-3

Q301
Q302
Q303
Q304
Q305
Q306
Q361
Q362
Q366
Q367

B-5
B-5
B-1
B-1
B-2
C-5
C-5
C-5
C-5
C-5

CX-JDS22/JDS33
6-15. SCHEMATIC DIAGRAM AMP BOARD

Q303
2SC3052EF-T1-LEF

R317
* R317
*
470 : JDS33
0 : JDS22
R364
2.2k

C304
4.7
50V

R361
22k

R303
22k

R305 22k

C302
1000p

R306 22k

Q306
2SC3052EF-T1-LEF

C361
100
50V

C303
4.7
50V

R359
0

C314
10p

C311
10p
C312
10p

JR301
0

R314
22k
C305
470p

C363
10
100V

R362
10k

R316
22k

TH361
100K

R363
1k

C362
10
100V

R352
4.7k
R355
10 k

R376
220

R302
1k

R391
0

R371
220

R392
0

* R318
470 : JDS33
0 : JDS22

R369
100k
C360
0.1

IC301

CN301
13P

C313
10p

R360
2.2k

R312
100

R313
22k

R315
22k

R353
22k

R301
1k

R351
22k

R365
4.7k

Q362
2SA1235TP-1EF

R309
1k

R354
22k

C321
470
10V

Q361
2SC3052EF-T1-LEF

C306 470p

R307
470

R311 100

R308
470

R310 1k

Q305
2SA1235TP-1EF

Q304
2SC3052EF
-T1-LEF

C301 1000p

R350
47k

C308
2.2
50V

R304 22k

R319
4.7k

R320
4.7k

C307
2.2
50V

R318
*

R356
10 k
R370
1k

C364
0.01

R377
220

Q367
2SC5625

28

R374
22k

C365
0.01

R372
220

R373
47k

Q366
2SA1514K

* IC301
JDS22 : STK403-120
JDS33 : STK403-130-E

JR303 0

R324
0.22
2W

D363
MC2838

R322
0.22
2W

R323
0.22
2W

R321
0.22
2W

EP301
EARTH,PLATE
* R358
220 : JDS33
0 : JDS22
R344
220

* R338
22K : JDS33
47K : JDS22
R330
220

R336
10k
R338 *
R340
4.7k

R358
*

JDS22

R346
4.7k

R343
220

* R349
220 : JDS33
0 : JDS22

R334 4.7k

Q302
2SA2026

36

R337 *

R345
4.7k

D361
MC2838

OVER LOAD
DET

36

R335 10K

C319
0.047
R347
22k
JDS22

R342
47k
D362
MC2836

CX-JDS22/JDS33

R349
*

R339
4.7k

R332
22k

C320
0.047

JDS22
R348
22k

* R337
22K : JDS33
47K : JDS22

Q301
2SA2026

R341
47k

R329
220
JDS22
R331
4.7k

R333
22K

CX-JDS22/JDS33
6-16. PRINTED WIRING BOARD POWER BOARD

See page 21 for Circuit Boards Location.

:Uses unleaded solder.

AC IN

E51
E51

E51

E51
MX

MX
E51

S001
E51

MX

E51

120V
220V

PT002

230V-240V

PT001
MX

WH001

MAIN BOARD
WH101
(Page 26)

E51
MX
5

E51

H
MAIN BOARD
WH102
(Page 26)

WH002

15
15

E51

K
1

PT001
PT002

KA

K
A

MX

A
K

* Not replaceable:
Bult in transformer
478

CX-JDS22/JDS33

37

37

VOLTAGE
SELECTOR

CX-JDS22/JDS33

RY001
SDT-S-109MR

6-17. SCHEMATIC DIAGRAM POWER BOARD

RY002
G5PA-2

CN001
2P
PT002

T001
ACW001

T002

JW018

JW026
JW025

JW028

JW030

JW024

JW007

WH002
7P

JW020

(2/3)

S001
JW019

28

JW021

JW017

JW009

JW008

JW010

C004
470 16V

(2/3)
28

C005
0.1
WH001
5P
PT001

PT003
PT004

D003
R012
MC2838-T112-1 1k

R014
100

R013
22k

C011
*

R011
1k

* C011
0.15/50V : JDS22 (MX)
0.22/50V : EXCEPT JDS22(MX)

CX-JDS22/JDS33

38

38

D001
MC2836

D002
MC2838
-T112-1

CX-JDS22/JDS33

IC Block Diagrams
BD Board

XTACN

IOVSS0

XTSL

NC

LMUT
91

XRST

SYSM

92

DATA

93

VSS

94

CLOK
XLAT

95

VDD

EXCK
SBSO
SQCK
SQSO

115 114 113 112 111 110 109 108

120 119 118 117 116

107 106 105 104 103 102 101 100 99 98 97 96

SENS

ATCK
SCLK

WFCK

XUGF

XPCK

C2PO

GFS

SCOR

VDD

C4M

WDCK

NC

COUT

IC101 CXD3059AR

CPU INTERFACE

SERVO
INTERFACE
90 RMUT
89 IOVDD0
88 NC
87 AVDD2
D/A
COVERTER
MIRR 1
DFCT 2
FOK 3

86 AOUT2
85 VREFR

LPF

MIRR
DFCT
FOK

84 AVSS2
83 AVSS1

VSS 4

82 VREFL
81 AOUT1

LPF

LOCK 5
MDP 6

80 AVDD1

SSTP 7

79 XVDD

IOVSS1 8
SFDR
SRDR
TFDR
TRDR
FFDR
FRDR

78 XTAI
77 XTAO

CLOCK
GENERATOR

9
10
11
12
13
14

76 XVSS

PWM
GENERATOR

75 NC

SERVO
AUTO
SEQUENCER

DIGITAL
CLV

74 IOVSS2
73 TES1
72 TEST

IOVDD1 15
AVDD0 16

SERVO
DSP

AVSS0 17

71 DOUT

DIGITAL OUT

70 IOVDD2

NC 18
A/D
CONVERTER

69 EMPHI
68 EMPH

E
F
TEI
TEO

67 VDD

19
20
21
22

D/A
INTERFACE

TE

SELECTOR
ERROR
CORRECTOR

FEI 23
FEO 24
VC 25

66 BCK
65 PCMD
64 VSS

32k
RAM

63 LRCK

FE

VC

EFM
DEMODULATOR
A
B
C
D

26
27
28
29

SUM

SUB CODE
PROCESSOR

NC 30

ASYNMMETRY
CORRECTOR
ATT

EQ

DIGITAL
PLL

AMP

DC/DC
CONVERTER

62 LRCKI
61 PCMDI

DDVROUT
DDVRSEN

NC

BCKI

DDCR

AVDD5

AVSS5

CLTV
FILO
FILI
PCO

AVSS3

VPCO
VCTL

RFACI

BIAS
ASYI
ASYO

60

AVDD3

55 56 57 58 59

AVSS4

54

RFACO

42 43 44 45 46 47 48 49 50 51 52 53

RFC

37 38 39 40 41

NC

LD

35 36

EQ_IN

PDSENS

AC_SUM

RFDCO

AVDD4

31 32 33 34

PD

APC

39

40

49

50

51

52

53

54

55

56

57

58

59

60

61

62

63

64

AD3

AD2

AD1

AD0

VSS

VDD

CKO

VDDX

XO

XI

VSSX

TEST

MIMD

VSSP

VCOI

AD7 46
AD9 44
Bus
Switch

AD5 48

VC0

AD10 43
MCU. I/F

round & limit

A1

A3

round & limit

A2

ALU

AY

Audio I/F

Sub code
I/F

DIT

PIO1
PIO0
VSS
CKI

VDD
TXO
SFSY
SBSY
DATA

PIO2

PIO3

26

A0

AX

1Mbit
SRAM

PIO4

27

Y-Bus

X-Bus

C-Pointer
register

PIO5

28

MAC

MZ

Y-Pointer
register

SRAM I/F

PIO6

29

MY

register
XO X1 X2
Y0 Y1 Y2

X-Pointer
register

AD11 39
CROM
4k word

BUCK 36

MX

VDDM 40
CRAM
4k word

PIO7

30

Instruction
Decoder

SRMSTB 41
ERAM
2k word

WE

31

Program
Control

YRAM
4k word

CCE 37
Address Calc.
2sets

General
In/Output Port

32

PRAM

POM

XRAM
4k word

AD12 38
SRAM/
DRAM I/F

OE 35

CDP Cont
I/F

CAS 34

AD4

CX-JDS22/JDS33

IC301 TC94A34FG-002

25
24
23
22
21
20
19
18
17

RAS 33
16 LRCKIA

15 BCKIA

14 SDI0

13 LRCKO

12 BCKO

11 SDO0

10 VSS

9 VDDT

8 MIACK

VDDT 42
7 MICK

6 MIDIO

5 MILP

AD8 45
4 MICS

3 STANBY

AD6 47

2 RESET

Timing
Generator

1 VDDP

10

11

12

13

14

15

16

17

18

19

20

PB1N

PB1P

PB2P

PB2N

FGND

PB2O

PB1O

VOLIN1

VOLIN2

MGND

TRE11

TRE12

TRE21

YRE22

MID21

MID22

VDD

SI

SC

VEE

REC1O

REC1N

REC2N

REC2O

INC2
INC1
INB2
INB1
INA2
INA1
RVFIL2
RVFIL1
OUT1

OUT2

BAS12
BAS11
BAS22
BAS21
MID12
MID11

FRONT
VOLUME

10

FRONT
VOLUME

TREBLE

CH1OUTF

VREF

CH1OUTR

MUTING

CH2OUTF

CH2OUTR

POWVCC

VREFIN

GND

CH2RIN

CH2FIN

CH1RIN

CH1FIN

1 2

SW

OPIN
OPIN+

PREVCC

OPOUT

OUTVREF

CH4CAPA

CH4IN

CH3FIN

CH3RIN

GND

MUTE

POWVCC

CH3OUTF

CH3OUTR

CH4OUTF

CH4OUTR

CX-JDS22/JDS33

IC251 FAN8040G3

28
27
26
25
24
23
22
21
20
19
18
17
16
15

D
D
D
D

+
INTERFACE
LEVEL SHIFT

INTERFACE
INTERFACE

D
D
D
D

11
12
13
14

MAIN Board

IC401 BD3882FV

40
39
38
37
36
35
34
33
32
31
30
29
28
27
26
25
24
23
22
21

BASS
MIDDLE

BASS

REAR
VOLUME

REAR
VOLUME

TREBLE

MIDDLE

LOGIC
CONTROL

41

CX-JDS22/JDS33

PANEL Board

VSS

VDD

GRID1

GRID2

GRID3

GRID4

SEG24/GRID5

SEG23/GRID6

SEG22/GRID7

SEG21/GRID8

SEG20/GRID9

IC601 uPD16315GB-3BS

44

43

42

41

40

39

38

37

36

35

34

Grid driver
Multiplexed driver

33 SEG19/GRID10

Command decoder
LED1

LED2

LED3

LED4

OSC

DOUT

DIN

CLK

27 SEG14/KS14

STB

26 SEG13/KS13

Serial
interface

12-bit shift register

31 SEG17/GRID12

Data selector

OSC

Display memory
24 bits x 12 words

Timing generator
key scan

30 VEE

24-bit output latch

4-bit latch

32 SEG18/GRID11

Key data memory

(2 x 16 bits)

29 SEG16/KS16
28 SEG15/KS15

25 SEG12/KS12
24 SEG11/KS11

segment driver

KEY1 10
KEY2 11

42

12

13

14

15

16

17

18

19

20

21

22

VSS

VDD

SEG1/KS1

SEG2/KS2

SEG3/KS3

SEG4/KS4

SEG5/KS5

SEG6/KS6

SEG7/KS7

SEG8/KS8

SEG9/KS9

23 SEG10/KS10

CX-JDS22/JDS33

IC Pin Function Description

PANEL BOARD IC604 M30302MCP-A07FPU0 (SYSTEM CONTROLLER)
Pin No.

Pin Name

I/O

P96

Solenoid control signal output to the tape deck

P95

PLAY switch signal input from the tape deck

P94

Record protect detect switch signal input (rear)(JDS22: Not use/JDS33:Use)

P93

Record protect detect switch signal input (f)

P92

PACK detect switch signal input

P91

Tape motor control signal output

P90

Remote control signal input from the remote sensor

Destination setting input terminal (Connected to ground.)

BYTE

CNVSS

Description

Not used

10

XCIN

Oscillation circuit signal input for the real time clock

11

XCOUT

Oscillation circuit signal output for the real time clock

12

RES

Reset signal input

13

XOUT

Oscillation circuit signal output for the system main clock

14

VSS

Ground terminal

15

XIN

16

VCC1

Oscillation circuit signal input for the system main clock

17

P85/NM1

18

P84/INT2

Clock signal input from the tuner (Connected to ground.)

19

P83/INT1

SCOR signal input from the CD unit

20

P82/INT0

Power down detection signal input

21

P81

Main power control signal output

22

P80

AMP control signal output

23

P77

Muting control signal output to the tuner Level control signal output for i-Bass

24

P76

Bias control signal output to the tape deck

25

P75

Playback selection signal output for the tape deck

26

P74

Tuner tuned status signal input from the tuner

Power supply terminal (+3.3 V)

Not used (pull up)

27

P73/CTS2

Stereo detection signal input from the tuner

28

P72/CLK2

Clock output to the MP3 IC

29

P71/RXD2

I/O

The MP3 IC data signal

30

P70/TXD2

I/O

The MP3 IC data signal

31

P67/TXD1

Data output to the CD unit

32

P66/RXD1

SENS signal input from the CD unit

33

P65/CLK1

Clock output to the CD unit

34

P64/CTS1

Not used

35

P63/TXDO

Data output to the LCD driver

36

P62/RXDO

Chip select signal output to the LCD driver

37

P61/CLKO

Clock signal output to the LCD driver

38

P60/CTSO

Data output to the tuner and function IC

39

P57/CLKOUT

Clock output to the function IC

40

P56

Latch signal output to the tuner

41

P55

Not used (pull down)

42

P54

Clock output to the tuner

43

P53

Data input from the tuner

44

P52

RDS signal input from the tuner (Connected to ground.)

45

P51

Standby LED control signal output

46

P50

Not used (pull up)

47

P47

CD motor control signal output

43

CX-JDS22/JDS33

Pin No.

Pin Name

I/O

48

P46

CD motor drivel signal output (+M2)

49

P45

CD motor drivel signal output (M2)

50

P44

CD motor drive signal output (+M1)

44

Description

51

P43

CD motor drive signal output (M1)

52

P42

LED (i-Bass) control signal output

53

P41

Switch8 signal input from the CD mechanism

54

P40

Switch5 signal input from the CD mechanism

55

P37

Switch6 signal input from the CD mechanism

56

P36

Switch2 signal input from the CD mechanism

57

P35

Switch7 signal input from the CD mechanism

58

P34

Switch1 signal input from the CD mechanism

59

P33

Switch3 signal input from the CD mechanism

60

P32

XTCN signal output to the CD unit

61

P31

Reset signal output to the MP3 IC

62

VCC2

Power supply terminal (+3.3 V)

63

P30

MICS signal output to the MP3 IC

64

VSS2

Ground terminal

65

P27

Acknowledge signal input from the MP3 IC

66

P26

Strobe signal output to the MP3 IC

67

P25

Request signal input from the MP3 IC

68

P24

Latch pulse signal output to the MP3 IC

69

P23

XLT signal output to the CD unit

70

P22

Reset signal output to the CD unit

71

P21

Not used

72

P20

Not used

73

P17

Not used

74

P16/INT4

SENS signal from the Function Key

75

P15/INT3

MIC-ON/OFF signal input from MIC JACK

76

P14

Not used

77

P13

Not used

78

P12

Not used

79

P11

Not used

80

P10

Not used

81

P07/AN07

LED6 drive signal output

82

P06/AN06

LED5 drive signal output

83

P05/AN05

LED4 drive signal output

84

P04/AN04

LED3 drive signal output

85

P03/AN03

LED2 drive signal output

86

P02/AN02

LED1 drive signal output

87

P01/AN01

Voltage detection signal input

88

P00/AN00

LED control signal output

89

P107/AN7

Key1 input

90

P106/AN6

Key2 input

91

P105/AN5

Key3 input

92

P104/AN4

Model signal input

93

P103/AN3

SUFFIX signal input

94

P102/AN2

END switch signal input from the tape deck

95

P101/AN1

Treble signal input from the rotary encoder

96

AVSS

Ground terminal

CX-JDS22/JDS33

Pin No.

Pin Name

I/O

Description

97

P100/AN0

Volume signal input from the rotary encoder

98

VREF

Reference voltage

99

AVCC

Power supply terminal (+3.3V)

100

P97

Motor control signal output to the tape deck

45

CX-JDS22/JDS33
SECTION 7
EXPLODED VIEWS
NOTE:
-XX and -X mean standardized parts, so they
may have some difference from the original
one.
Items marked * are not stocked since they
are seldom required for routine service.
Some delay should be anticipated when
ordering these items.

The mechanical parts with no reference

number in the exploded views are not supplied.
Abbreviation
E51
: Chilean and Peruvian models
MX
: Mexican model

The components identified by mark 0 or

dotted line with mark 0 are critical for safety.
Replace only with part number specified.

7-1. OVERALL SECTION

6
3

#3

#2

2
3

TU803
not supplied

front section

CD mechanism section-1
#1

M871

2
7

chassis section

Ref. No.

Part No.

Description

1
2
3
4
5

3-254-142-01
3-363-099-32
3-254-143-11
2-515-154-01
2-515-156-02

SCREW (B3), (+) BV TAPPING

SCREW (CASE 3 TP2)
SCREW (B3), (+) BV TAPPING
PANEL, LEFT
PANEL, TOP

6
6

2-515-153-02 CABINET, REAR (MX)

2-515-153-12 CABINET, REAR (E51)

46

Remark

Ref. No.

Part No.

Description

7
M871
TU803

2-515-155-01 PANEL, RIGHT

1-787-344-11 FAN, DC
1-693-628-11 TUNER (FM/AM)

#1
#2
#3

7-685-245-19 SCREW +KTP 3X6 TYPE2 NON-SLIT

7-685-650-79 SCREW +BVTP 3X16 TYPE2 IT-3
7-685-645-79 SCREW +BVTP 3X6 TYPE2 IT-3

Remark

CX-JDS22/JDS33

7-2. FRONT SECTION-1

65
57

90

66

58
68

62
56

52

81

63

59

61

81
64
69

52

60

70

80

83

91

82

not
supplied

72

74

54

52

73

89

84

53
not
supplied

52

87

71
55

81

67

52
85

not
supplied

52

79

51
78
not
supplied

75

77

86

88
76

52

not supplied

Ref. No.

Part No.

Description

51
52
53
54
54

2-515-182-01
4-951-620-01
2-515-186-01
2-515-187-01
2-515-187-11

REFLECTOR (VOL)
SCREW (2.6X8), +BVTP
GUIDE (LED VOL)
KNOB (RTRY AMS) (JDS33)
KNOB (RTRY AMS) (JDS22)

Remark

Ref. No.
67
68

1-832-038-11 CABLE, FLEXIBLE FLAT (27 CORE)

A-1101-540-A PANEL BOARD, COMPLETE
(including CONTACT BOARD) (JDS33: E51)

68

55
56
57
58
59

2-515-157-01
2-515-168-11
2-515-169-02
2-515-170-01
2-515-174-01

WINDOW (DISPLAY)
KEY (POWER)
REFLECTOR, POWER
KEY (CD)
KEY (OPE) (JDS33)

68

69
70

A-1101-542-A PANEL BOARD, COMPLETE

(including CONTACT BOARD) (JDS33: MX)
A-1101-564-A PANEL BOARD, COMPLETE
(including CONTACT BOARD) (JDS22: E51)
A-1101-566-A PANEL BOARD, COMPLETE
(including CONTACT BOARD) (JDS22: MX)
2-515-172-11 KEY (CD O/C)
2-580-316-02 GUIDE (LED IBS)

59
60
61
62
63

2-515-174-11
2-515-246-01
2-515-178-01
2-515-179-01
2-515-180-01

KEY (OPE) (JDS22)

SHEET (FL)
KEY (VOL A)
KEY (VOL B)
KEY (VOL C)

71
72
73
74

4-231-841-01
4-231-825-01
4-242-171-01
1-796-351-51

64
65
66

2-515-181-01 KEY (VOL D)

2-515-171-02 KEY (CD SYNC)
2-515-175-02 KEY (REC)

68

74

Part No.

Description

Remark

SPRING (HEART CAM-B)

CAM (B), HEART
DAMPER 150 N
MECHANISM, SIGNAL CASSETTE
(CMAL1Z240A) (JDS33)
1-796-352-41 DECK, MECHANICAL (CMAL5Z220A) (JDS22)
(Continued on page 48)

47

CX-JDS22/JDS33

7-3. FRONT SECTION-2

65
57

90

66

58
68

62
56

52

81

63

59

61

81
64
69

52

60

70

80

83

91

82

not
supplied

72

74

54

52

73

89

84

53
not
supplied

52

87

71
55

81

67

52
85

52

not
supplied

79

51
78
not
supplied

75

77

86

88
76

52

not supplied

Ref. No.

Part No.

(Continued from page 47)

75
2-586-559-01
76
2-515-151-02
77
2-515-245-01
78
2-515-152-51
78
2-515-152-61
79
80
81
82
83

48

4-225-252-01
2-515-173-01
4-900-386-01
1-469-854-11
X-2059-794-1

Description
KNOB (MIC)
BOX, CASSETTE
SPRING (CASS)
PANEL, CASSETTE (JDS33)
PANEL, CASSETTE (JDS22)
CUSHION (FOOT)
SHEET (IBS)
SCREW
CORE, FERRITE
I-BASS ASSY SVC

Remark

Ref. No.

Part No.

Description

Remark

84
85
86
86
87

X-2059-792-1
X-2109-127-1
A-1115-978-A
A-1115-979-A
A-1115-980-A

BASS ASSY SVC

CABINET (FRONT) ASSY SVC
PAI/HP/MIC BOARD, COMPLETE (JDS33)
PAI/HP/MIC BOARD, COMPLETE (JDS22)
VOLME BOARD, COMPLETE (JDS33)

87
88
89
90
91

A-1115-981-A
2-515-150-01
X-2059-793-1
1-831-970-11
2-631-596-01

VOLME BOARD, COMPLETE (JDS22)

PLATE (VOL)
VOL ASSY SVC
CABLE, FLEXIBLE FLAT (31 CORE)
SHEET (VOL BLACK)

CX-JDS22/JDS33

7-4. CHASSIS SECTION

112
105
102

108
101
not
supplied

101

109
103
111

103

115

113

103

PT001
PT002

104

not
supplied

101

110

101
114

E51 model only

106

not
supplied

Ref. No.

Part No.

Description

101
102
103
104
105

3-254-142-01
2-515-258-01
4-900-386-01
3-905-609-31
X-2050-219-1

SCREW (B3), (+) BV TAPPING

HOLDER (MAIN)
SCREW
SCREW (TRANSISTOR)
HEAT SINK ASSY (30) (JDS33)

105
0 106
0 106
107
* 107

X-2055-754-1
1-827-226-31
1-830-384-11
3-703-244-00
3-703-571-12

108
108
109
109
110

A-1134-265-A
A-1134-271-A
A-1101-573-A
A-1101-588-A
A-1134-288-A

107

Remark

Ref. No.

Part No.

Description

110
110
110
111
112

A-1134-289-A
A-1134-296-A
A-1134-297-A
1-831-778-11
1-831-782-11

POWER BOARD, COMPLETE (JDS33: MX)

POWER BOARD, COMPLETE (JDS22: E51)
POWER BOARD, COMPLETE (JDS22: MX)
CABLE, FLEXIBLE FLAT (11 CORE)
CABLE, FLEXIBLE FLAT (11 CORE)

Remark

HEAT SINK ASSY (20) (JDS22)

CORD, POWER (MX)
CORD, POWER (E51)
BUSHING (2104), CORD (E51)
BUSHING (S) (4516), CORD (MX)

113
113
0 114
115
0 PT001

1-831-761-11
1-831-767-11
1-569-008-21
3-077-331-01
1-443-722-11

CABLE, FLEXIBLE FLAT (7 CORE) (JDS22)

CABLE, FLEXIBLE FLAT (8 CORE) (JDS33)
ADAPTOR, CONVERSION 2P (E51)
+BV3 (3-CR)
TRANSFORMER, POWER (JDS33: MX)

MAIN BOARD, COMPLETE (JDS33)

MAIN BOARD, COMPLETE (JDS22)
AMP BOARD, COMPLETE (JDS33)
AMP BOARD, COMPLETE (JDS22)
POWER BOARD, COMPLETE (JDS33: E51)

0 PT001
0 PT002
0 PT002

1-443-723-11 TRANSFORMER, POWER (JDS22: MX)

1-443-700-11 TRANSFORMER, POWER (JDS33: E51)
1-443-702-11 TRANSFORMER, POWER (JDS22: E51)

49

CX-JDS22/JDS33

7-5. CD MECHANISM SECTION-1

CD MECHANISM SECTION-2

156
153

157
156
156

155

155

154

156

154

159

162

158

S101

161

152

not
supplied

not
supplied

160

CONTACT board
including Ref. No. 68

151

#4
including Ref. No. 67

Ref. No.
151
152
153
154
155
156
0 157

50

Part No.

Description

4-951-620-01
2-515-252-02
2-515-158-01
4-985-672-01

SCREW (2.6X8), +BVTP

HOLDER (CD MECH)
PANEL, TRAY
SCREW (+PTPWHM2.6), FLOATING

Remark

4-227-045-11 SPRING (INSULATOR), COIL

4-227-549-11 INSULATOR
8-820-244-01 OPTICAL PICK-UP (KSM-215DCP/C2NP)

Ref. No.

Part No.

Description

158
159

1-827-992-11 WIRE (FLAT TYPE) (16 CORE)

A-1126-140-A BD BOARD, COMPLETE

160
161
162
S101
#4

3-087-053-01
1-828-400-51
1-831-938-11
1-771-853-11
7-685-646-71

+BVTP2.6 (3CR)
WIRE (FLAT TYPE) (27 CORE)
CABLE, FLEXIBLE FLAT (13 CORE)
SWITCH, DETECTION (LIMIT)
SCREW +BVTP 3X8 TYPE2 IT-3

Remark

CX-JDS22/JDS33

7-6. CD MECHANISM SECTION-2

204

not
supplied

203
not
supplied
not
supplied

203

not
supplied

202

not
supplied

201

Ref. No.
201
202
203
204

Part No.

Description

1-797-193-12
2-632-062-01
2-633-134-01
2-598-664-01

MECHANICAL, CD
BELT (DLM3A)
SCREW (B2.6), (+) BV TAPPING
COVER (CD)

Remark

51

CX-JDS22/JDS33
SECTION 8
ELECTRICAL PARTS LIST

AMP
NOTE:
Due to standardization, replacements in the
parts list may be different from the parts
specified in the diagrams or the components
used on the set.
-XX and -X mean standardized parts, so they
may have some difference from the original
one.
Items marked * are not stocked since they
are seldom required for routine service.
Some delay should be anticipated when
ordering these items.
CAPACITORS
uF: F
Ref. No.

Part No.

COILS
uH: H
RESISTORS
All resistors are in ohms.
METAL: Metal-film resistor.
METAL OXIDE: Metal oxide-film resistor.
F: nonflammable
SEMICONDUCTORS
In each case, u: , for example:
uA. . : A. . , uPA. . , PA. . ,
uPB. . : PB. . , uPC. . , PC. . ,
uPD. . : PD. .

Description

Remark

A-1101-573-A AMP BOARD, COMPLETE (JDS33)

A-1101-588-A AMP BOARD, COMPLETE (JDS22)
********************

C301
C302
C303
C304
C305

1-162-971-11
1-162-971-11
1-126-963-11
1-126-963-11
1-164-315-11

CERAMIC CHIP
CERAMIC CHIP
ELECT
ELECT
CERAMIC CHIP

0.001uF
0.001uF
4.7uF
4.7uF
470PF

10%
10%
20%
20%
5%

50V
50V
50V
50V
50V

C306
C307
C308
C311
C312

1-164-315-11
1-126-961-11
1-126-961-11
1-162-915-11
1-162-915-11

CERAMIC CHIP
ELECT
ELECT
CERAMIC CHIP
CERAMIC CHIP

470PF
2.2uF
2.2uF
10PF
10PF

5%
20%
20%
0.5PF
0.5PF

50V
50V
50V
50V
50V

C313
C314
C319
C320
C321

1-162-915-11
1-162-915-11
1-165-176-11
1-165-176-11
1-126-925-91

CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
ELECT

10PF
10PF
0.047uF
0.047uF
470uF

0.5PF
0.5PF
10%
10%
20%

50V
50V
16V
16V
10V

C360
C361
C362
C363
C364

1-164-156-11
1-126-968-11
1-110-518-91
1-110-518-91
1-162-970-11

CERAMIC CHIP
ELECT
ELECT
ELECT
CERAMIC CHIP

0.1uF
100uF
10uF
10uF
0.01uF

20%
20%
20%
10%

25V
50V
100V
100V
25V

C365

1-162-970-11 CERAMIC CHIP

0.01uF

10%

25V

CN301

1-778-982-21 CONNECTOR, BOARD TO BOARD 13P

Part No.

The components identified by mark 0 or

dotted line with mark 0 are critical for safety.
Replace only with part number specified.

Abbreviation
E51
: Chilean and Peruvian models
MX
: Mexican model

Description

Remark

< TRANSISTOR >

< CAPACITOR >

< CONNECTOR >

Ref. No.

When indicating parts by reference number,

please include the board name.

Q301
Q302
Q303
Q304
Q305

6-551-270-01
6-551-270-01
8-729-120-28
8-729-120-28
8-729-600-22

TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR

2SA2026
2SA2026
2SC1623-L5L6
2SC1623-L5L6
2SA1235-F

Q306
Q361
Q362
Q366
Q367

8-729-120-28
8-729-120-28
8-729-600-22
6-550-327-01
6-551-268-01

TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR

2SC1623-L5L6
2SC1623-L5L6
2SA1235-F
2SA1514K (S)
2SC5625

< RESISTOR >

R301
R302
R303
R304
R305

1-216-821-11
1-216-821-11
1-216-837-11
1-216-837-11
1-216-837-11

METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP

1K
1K
22K
22K
22K

5%
5%
5%
5%
5%

1/10W
1/10W
1/10W
1/10W
1/10W

R306
R307
R308
R309
R310

1-216-837-11
1-216-817-11
1-216-817-11
1-216-821-11
1-216-821-11

METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP

22K
470
470
1K
1K

5%
5%
5%
5%
5%

1/10W
1/10W
1/10W
1/10W
1/10W

R311
R312
R313
R314
R315

1-216-809-11
1-216-809-11
1-216-837-11
1-216-837-11
1-216-837-11

METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP

100
100
22K
22K
22K

5%
5%
5%
5%
5%

1/10W
1/10W
1/10W
1/10W
1/10W

R316
R317

1-216-837-11 METAL CHIP

1-216-817-11 METAL CHIP

22K
470

5%
5%

1/10W
1/10W
(JDS33)

R317
R318

1-216-864-11 SHORT CHIP

1-216-817-11 METAL CHIP

0 (JDS22)
470
5%

R318

1-216-864-11 SHORT CHIP

0 (JDS22)

R319
R320
0 R321
0 R322
0 R323

1-216-829-11
1-216-829-11
1-216-361-31
1-216-361-31
1-216-361-31

METAL CHIP
METAL CHIP
METAL OXIDE
METAL OXIDE
METAL OXIDE

4.7K
4.7K
0.22
0.22
0.22

5%
5%
5%
5%
5%

1/10W
1/10W
2W
2W
2W

0 R324
R329
R330
R331
R332

1-216-361-31
1-216-813-11
1-216-813-11
1-216-829-11
1-216-837-11

METAL OXIDE
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP

0.22
220
220
4.7K
22K

5%
5%
5%
5%
5%

2W
1/10W
1/10W
1/10W
1/10W
(JDS22)

< DIODE >

D361
D362
D363

8-719-000-08 DIODE MC2838

8-719-000-07 DIODE MC2836
8-719-000-08 DIODE MC2838
< EARTH TERMINAL >

* EP301

1-537-738-21 TERMINAL, EARTH

< IC >

IC301
IC301

6-600-221-01 IC STK403-130-E (JDS33)

6-705-853-01 IC STK403-120 (JDS22)
< JUMPER RESISTOR >

JR301
JR303

52

1-216-864-11 SHORT CHIP

1-216-864-11 SHORT CHIP

0
0

1/10W
(JDS33)

CX-JDS22/JDS33
AMP
Ref. No.

Part No.

Description

Remark

R333

1-216-837-11 METAL CHIP

22K

5%

1/10W
(JDS22)
1/10W
1/10W
1/10W
1/10W
(JDS33)

R334
R335
R336
R337

1-216-829-11
1-216-833-11
1-216-833-11
1-216-837-11

METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP

4.7K
10K
10K
22K

5%
5%
5%
5%

R337

1-216-841-11 METAL CHIP

47K

5%

R338

1-216-837-11 METAL CHIP

22K

5%

R338

1-216-841-11 METAL CHIP

47K

5%

R339
R340

1-216-829-11 METAL CHIP

1-216-829-11 METAL CHIP

4.7K
4.7K

5%
5%

1/10W
(JDS22)
1/10W
(JDS33)
1/10W
(JDS22)
1/10W
1/10W

R341
R342
R343
R344
R345

1-216-841-11
1-216-841-11
1-216-813-11
1-216-813-11
1-216-829-11

METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP

47K
47K
220
220
4.7K

5%
5%
5%
5%
5%

R346
R347

1-216-829-11 METAL CHIP

1-216-837-11 METAL CHIP

4.7K
22K

5%
5%

R348

1-216-837-11 METAL CHIP

22K

5%

R349

1-216-813-11 METAL CHIP

220

5%

R349

1-216-864-11 SHORT CHIP

0 (JDS22)

R350
R351
R352
R353
R354

1-216-841-11
1-216-837-11
1-216-829-11
1-216-837-11
1-216-837-11

METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP

47K
22K
4.7K
22K
22K

5%
5%
5%
5%
5%

1/10W
1/10W
1/10W
1/10W
1/10W

R355
R356
R358

1-216-833-11 METAL CHIP

1-216-833-11 METAL CHIP
1-216-813-11 METAL CHIP

10K
10K
220

5%
5%
5%

1/10W
1/10W
1/10W
(JDS33)

R358
R359

1-216-864-11 SHORT CHIP

1-216-864-11 SHORT CHIP

0 (JDS22)
0

R360
R361
R362
R363
R364

1-216-825-11
1-216-837-11
1-216-833-11
1-216-821-11
1-216-825-11

METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP

2.2K
22K
10K
1K
2.2K

5%
5%
5%
5%
5%

1/10W
1/10W
1/10W
1/10W
1/10W

R365
R369
R370
R371
R372

1-216-829-11
1-216-845-11
1-216-821-11
1-216-813-11
1-216-813-11

METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP

4.7K
100K
1K
220
220

5%
5%
5%
5%
5%

1/10W
1/10W
1/10W
1/10W
1/10W

R373
R374
R376
R377
R391

1-216-841-11
1-216-837-11
1-216-813-11
1-216-813-11
1-216-864-11

METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
SHORT CHIP

47K
22K
220
220
0

5%
5%
5%
5%

1/10W
1/10W
1/10W
1/10W

R392

1-216-864-11 SHORT CHIP

Ref. No.

Part No.

Description

BD
Remark

A-1126-140-A BD BOARD, COMPLETE

*******************
< CAPACITOR >
C10
C11
C14
C15
C16

1-165-989-11
1-165-989-11
1-164-360-11
1-164-360-11
1-115-156-11

CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP

10uF
10uF
0.1uF
0.1uF
1uF

10%
10%

6.3V
6.3V
16V
16V
10V

C17
C18
C111
C112
C113

1-126-246-11
1-162-964-11
1-162-967-11
1-164-315-11
1-162-967-11

ELECT CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP

220uF
0.001uF
0.0033uF
470PF
0.0033uF

20%
10%
10%
5%
10%

4V
50V
50V
50V
50V

1/10W
1/10W
1/10W
1/10W
1/10W

C114
C115
C116
C122
C123

1-164-315-11
1-164-360-11
1-128-995-21
1-107-826-11
1-107-826-11

CERAMIC CHIP
CERAMIC CHIP
ELECT CHIP
CERAMIC CHIP
CERAMIC CHIP

470PF
0.1uF
100uF
0.1uF
0.1uF

5%

50V
16V
10V
16V
16V

1/10W
1/10W
(JDS22)
1/10W
(JDS22)
1/10W
(JDS33)

C124
C125
C131
C132
C133

1-162-959-11
1-164-360-11
1-162-927-11
1-117-863-11
1-162-970-11

CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP

330PF
0.1uF
100PF
0.47uF
0.01uF

5%
5%
10%
10%

50V
16V
50V
6.3V
25V

C134
C141
C142
C143
C151

1-164-360-11
1-107-826-11
1-162-965-11
1-164-360-11
1-128-995-21

CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
ELECT CHIP

0.1uF
0.1uF
10%
0.0015uF 10%
0.1uF
100uF
20%

16V
16V
50V
16V
10V

C161
C162
C163
C171
C172

1-164-360-11
1-164-360-11
1-164-360-11
1-162-919-11
1-162-920-11

CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP

0.1uF
0.1uF
0.1uF
22PF
27PF

5%
5%

16V
16V
16V
50V
50V

C174
C181
C182
C183
C184

1-164-360-11
1-164-360-11
1-164-360-11
1-124-778-00
1-124-778-00

CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
ELECT CHIP
ELECT CHIP

0.1uF
0.1uF
0.1uF
22uF
22uF

20%
20%

16V
16V
16V
6.3V
6.3V

C185
C186
C194
C195
C196

1-164-315-11
1-164-315-11
1-164-360-11
1-164-360-11
1-164-360-11

CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP

470PF
470PF
0.1uF
0.1uF
0.1uF

5%
5%

50V
50V
16V
16V
16V

C201
C203
C209
C210
C211

1-128-995-21
1-128-995-21
1-162-970-11
1-107-826-11
1-164-230-11

ELECT CHIP
ELECT CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP

100uF
100uF
0.01uF
0.1uF
220PF

20%
20%
10%
10%
5%

10V
10V
25V
16V
50V

C212
C213
C251
C252
C255

1-162-919-11
1-162-919-11
1-162-969-11
1-164-360-11
1-164-360-11

CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP

22PF
5%
22PF
5%
0.0068uF 10%
0.1uF
0.1uF

50V
50V
25V
16V
16V

C257
C258
C259
C260

1-164-360-11
1-164-360-11
1-164-360-11
1-128-394-11

CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
ELECT CHIP

0.1uF
0.1uF
0.1uF
220uF

16V
16V
16V
10V

< THERMISTOR >

TH361 1-805-217-21 THERMISTOR (1012)
*************************************************************

20%
10%
10%

20%

53

CX-JDS22/JDS33
BD

CONTACT

Ref. No.

Part No.

Description

Remark

C302

1-164-360-11 CERAMIC CHIP

0.1uF

C303
C305
C306
C307
C308

1-164-360-11
1-126-246-11
1-164-360-11
1-164-360-11
1-126-208-21

CERAMIC CHIP
ELECT CHIP
CERAMIC CHIP
CERAMIC CHIP
ELECT CHIP

0.1uF
220uF
0.1uF
0.1uF
47uF

C309
C310
C311
C312
C313

1-164-360-11
1-164-360-11
1-164-360-11
1-164-360-11
1-164-360-11

CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP

0.1uF
0.1uF
0.1uF
0.1uF
0.1uF

C314
C315
C316
C317
C318

1-126-208-21
1-107-826-11
1-162-966-11
1-162-970-11
1-162-970-11

ELECT CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP

47uF
0.1uF
0.0022uF
0.01uF
0.01uF

C320

1-216-864-11 SHORT CHIP

16V

20%

20%

16V
4V
16V
16V
4V
16V
16V
16V
16V
16V

20%
10%
10%
10%
10%

4V
16V
50V
25V
25V

Ref. No.

Part No.

Description

R167
R171
R172
R173

1-216-809-11
1-216-817-11
1-216-857-11
1-216-295-91

METAL CHIP
METAL CHIP
METAL CHIP
SHORT CHIP

5%
5%
5%

1/10W
1/10W
1/10W

Remark

R181
R182
R191
R201
R203

1-216-809-11
1-216-809-11
1-216-864-11
1-500-445-21
1-216-864-11

METAL CHIP
100
5%
METAL CHIP
100
5%
SHORT CHIP
0
FERRITE, EMI (SMD) (2012)
SHORT CHIP
0

1/10W
1/10W

R204
R205
R251
R252
R253

1-500-445-21
1-216-864-11
1-216-833-11
1-216-837-11
1-216-833-11

FERRITE, EMI (SMD) (2012)

SHORT CHIP
0
METAL CHIP
10K
5%
METAL CHIP
22K
5%
METAL CHIP
10K
5%

R301
R302
R303
R305
R306

1-216-845-11
1-216-833-11
1-216-845-11
1-216-845-11
1-216-864-11

METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
SHORT CHIP

100K
10K
100K
100K
0

5%
5%
5%
5%

1/10W
1/10W
1/10W
1/10W

R307
R313
R351
R352
R353

1-216-833-11
1-216-813-11
1-216-809-11
1-216-809-11
1-216-809-11

METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP

10K
220
100
100
100

5%
5%
5%
5%
5%

1/10W
1/10W
1/10W
1/10W
1/10W

R354
R401
R402
R403
R404

1-216-809-11
1-216-809-11
1-216-809-11
1-216-809-11
1-216-809-11

METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP

100
100
100
100
100

5%
5%
5%
5%
5%

1/10W
1/10W
1/10W
1/10W
1/10W

R405
R406
R407
R408
R409

1-216-809-11
1-216-809-11
1-216-809-11
1-216-809-11
1-216-809-11

METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP

100
100
100
100
100

5%
5%
5%
5%
5%

1/10W
1/10W
1/10W
1/10W
1/10W

R410
R411
R412
R419
R502

1-216-809-11
1-216-809-11
1-216-809-11
1-216-809-11
1-216-864-11

METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
SHORT CHIP

100
100
100
100
0

5%
5%
5%
5%

1/10W
1/10W
1/10W
1/10W

100
470
1M
0

1/10W
1/10W
1/10W

< CONNECTOR >

CN101
CN201

1-770-425-51 CONNECTOR, FFC/FPC 16P

1-818-350-51 CONNECTOR, FFC (LIF (NON-ZIF)) 27P
< FERRITE BEAD >

FB301

1-500-445-21 FERRITE, EMI (SMD) (2012)

< IC >

IC101
IC251
IC301
IC303

8-752-425-12
6-708-516-01
6-705-365-01
6-705-807-01

IC
IC
IC
IC

CXD3059AR
FAN8040G3
TC94A34FG-002
BH15FB1WG

< TRANSISTOR >

Q10

6-551-120-01 TRANSISTOR

2SA2119K

< RESISTOR >

R10
R11
R12
R13
R111

1-216-791-11
1-216-864-11
1-216-845-11
1-218-446-11
1-216-821-11

METAL CHIP
SHORT CHIP
METAL CHIP
METAL CHIP
METAL CHIP

3.3
0
100K
1
1K

5%

1/10W

5%
5%
5%

1/10W
1/10W
1/10W

R112
R113
R114
R121
R131

1-216-835-11
1-216-821-11
1-216-835-11
1-216-835-11
1-216-857-11

METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP

15K
1K
15K
15K
1M

5%
5%
5%
5%
5%

1/10W
1/10W
1/10W
1/10W
1/10W

R132
R133
R141
R142
R143

1-216-833-11
1-216-848-11
1-216-829-11
1-216-821-11
1-216-827-11

METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP

10K
180K
4.7K
1K
3.3K

5%
5%
5%
5%
5%

1/10W
1/10W
1/10W
1/10W
1/10W

R151
R161
R162
R163
R165

1-216-864-11
1-216-809-11
1-216-841-11
1-216-809-11
1-216-864-11

SHORT CHIP
METAL CHIP
METAL CHIP
METAL CHIP
SHORT CHIP

0
100
47K
100
0

5%
5%
5%

1/10W
1/10W
1/10W

R166

1-216-821-11 METAL CHIP

1K

5%

1/10W

54

< VIBRATOR >

X171
1-767-408-21 VIBRATOR, CRYSTAL (16.9MHz)
*************************************************************
A-1101-540-A CONTACT BOARD
(including PANEL BOARD, COMPLETE) (JDS33: E51)
A-1101-542-A CONTACT BOARD
(including PANEL BOARD, COMPLETE) (JDS33: MX)
A-1101-564-A CONTACT BOARD
(including PANEL BOARD, COMPLETE) (JDS22: E51)
A-1101-566-A CONTACT BOARD
(including PANEL BOARD, COMPLETE) (JDS22: MX)
**************
< CONNECTOR >
CN605 1-779-295-11 CONNECTOR, FFC (LIF (NON-ZIF)) 27P
CN606 1-779-295-11 CONNECTOR, FFC (LIF (NON-ZIF)) 27P
*************************************************************

CX-JDS22/JDS33
MAIN
Ref. No.

Part No.

Description

Remark

A-1134-265-A MAIN BOARD, COMPLETE (JDS33)

A-1134-271-A MAIN BOARD, COMPLETE (JDS22)
*********************
2-515-250-01
2-599-828-01
3-254-142-01
7-685-645-79

HEAT SINK (REG) (JDS33)

HEAT SINK (REG-S) (JDS22)
SCREW (B3), (+) BV TAPPING (JDS33)
SCREW +BVTP 3X6 TYPE2 IT-3
< CAPACITOR >

C101
C102
C105
C106
C109

1-137-749-11
1-137-749-11
1-127-813-11
1-127-813-11
1-164-156-11

MYLAR
MYLAR
ELECT
ELECT
CERAMIC CHIP

0.1uF
0.1uF
3300uF
3300uF
0.1uF

C110
C111
C112
C113
C114

1-164-156-11
1-126-944-11
1-126-965-91
1-126-968-11
1-164-156-11

CERAMIC CHIP
ELECT
ELECT
ELECT
CERAMIC CHIP

0.1uF
3300uF
22uF
100uF
0.1uF

C115
C116
C117
C118
C119

1-162-968-11
1-162-974-11
1-126-947-11
1-126-933-11
1-126-967-11

CERAMIC CHIP
CERAMIC CHIP
ELECT
ELECT
ELECT

0.0047uF
0.01uF
47uF
100uF
47uF

10%

C120
C123
C124
C127
C128

1-126-927-11
1-115-156-11
1-115-156-11
1-164-156-11
1-162-927-11

ELECT
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP

2200uF
1uF
1uF
0.1uF
100PF

20%

C129
C151
C152
C171
C172

1-162-927-11
1-104-658-91
1-162-970-11
1-164-156-11
1-164-156-11

CERAMIC CHIP
ELECT
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP

100PF
100uF
0.01uF
0.1uF
0.1uF

C173
C174
C175
C176
C177

1-164-156-11
1-164-156-11
1-164-156-11
1-164-156-11
1-162-970-11

CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP

0.1uF
0.1uF
0.1uF
0.1uF
0.01uF

C178
C180
C401
C402
C403

1-162-970-11
1-164-156-11
1-104-658-91
1-104-658-91
1-127-715-91

CERAMIC CHIP
CERAMIC CHIP
ELECT
ELECT
CERAMIC CHIP

0.01uF
0.1uF
100uF
100uF
0.22uF

10%
20%
20%
10%

25V
25V
10V
10V
16V

C404
C405
C406
C407
C408

1-127-715-91
1-107-826-11
1-107-826-11
1-162-964-11
1-162-964-11

CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP

0.22uF
0.1uF
0.1uF
0.001uF
0.001uF

10%
10%
10%
10%
10%

16V
16V
16V
50V
50V

C409
C410
C411
C412
C413

1-162-964-11
1-162-964-11
1-162-970-11
1-162-970-11
1-162-970-11

CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP

0.001uF
0.001uF
0.01uF
0.01uF
0.01uF

10%
10%
10%
10%
10%

50V
50V
25V
25V
25V

C414
C415
C416
C419

1-162-970-11
1-162-970-11
1-162-970-11
1-115-467-11

CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP

0.01uF
0.01uF
0.01uF
0.22uF

10%
10%
10%
10%

25V
25V
25V
10V

20%
20%

20%
20%
20%

20%
20%
20%

5%
5%
20%
10%

10%

100V
100V
71V
71V
25V
25V
25V
50V
50V
25V
50V
50V
35V
16V
50V
10V
10V
10V
25V
50V
50V
10V
25V
25V
25V
25V
25V
25V
25V
25V

Ref. No.

Part No.

Description

Remark

C420

1-131-696-11 FILM

0.22uF

5%

50V

C421
C422
C423
C424
C425

1-165-176-11
1-115-467-11
1-131-696-11
1-165-176-11
1-162-970-11

CERAMIC CHIP
CERAMIC CHIP
FILM
CERAMIC CHIP
CERAMIC CHIP

0.047uF
0.22uF
0.22uF
0.047uF
0.01uF

10%
10%
5%
10%
10%

16V
10V
50V
16V
25V

C426
C427
C428
C429
C430

1-126-963-11
1-126-963-11
1-126-963-11
1-127-715-91
1-127-715-91

ELECT
ELECT
ELECT
CERAMIC CHIP
CERAMIC CHIP

4.7uF
4.7uF
4.7uF
0.22uF
0.22uF

20%
20%
20%
10%
10%

50V
50V
50V
16V
16V

C431
C432
C433
C434
C435

1-162-964-11
1-162-964-11
1-162-964-11
1-162-964-11
1-126-960-11

CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
ELECT

0.001uF
0.001uF
0.001uF
0.001uF
1uF

10%
10%
10%
10%
20%

50V
50V
50V
50V
50V

C436
C437
C438
C439
C440

1-126-960-11
1-164-315-11
1-164-315-11
1-165-621-91
1-165-621-91

ELECT
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP

1uF
470PF
470PF
0.1uF
0.1uF

20%
5%
5%

50V
50V
50V
50V
50V

C441
C442
C447
C448
C449

1-162-919-11
1-162-919-11
1-162-962-11
1-162-962-11
1-126-961-11

CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
ELECT

22PF
22PF
470PF
470PF
2.2uF

5%
5%
10%
10%
20%

50V
50V
50V
50V
50V

C451
C453
C479
C480
C501

1-165-621-91
1-165-621-91
1-126-960-11
1-126-960-11
1-164-156-11

CERAMIC CHIP
CERAMIC CHIP
ELECT
ELECT
CERAMIC CHIP

0.1uF
0.1uF
1uF
1uF
0.1uF

C502
C503
C504
C505
C506

1-164-230-11
1-162-966-11
1-162-968-11
1-104-658-91
1-162-966-11

CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
ELECT
CERAMIC CHIP

220PF
0.0022uF
0.0047uF
100uF
0.0022uF

5%
10%
10%
20%
10%

50V
50V
50V
10V
50V

C507
C508
C509
C510
C512

1-162-968-11
1-104-658-91
1-162-923-11
1-162-964-11
1-162-923-11

CERAMIC CHIP
ELECT
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP

0.0047uF
100uF
47PF
0.001uF
47PF

10%
20%
5%
10%
5%

50V
10V
50V
50V
50V

C513
C515
C516
C517
C518

1-162-964-11
1-164-218-11
1-162-968-11
1-164-218-11
1-162-968-11

CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP

0.001uF
180PF
0.0047uF
180PF
0.0047uF

10%
5%
10%
5%
10%

50V
50V
50V
50V
50V

C521
C523
C524
C525
C526

1-126-961-11
1-164-315-11
1-164-315-11
1-164-156-11
1-137-391-11

ELECT
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
MYLAR

2.2uF
470PF
470PF
0.1uF
0.0047uF

20%
5%
5%
5%

50V
50V
50V
25V
100V

C527
C528
C529
C530
C531

1-164-156-11
1-162-970-11
1-126-964-11
1-162-966-11
1-162-966-11

CERAMIC CHIP
CERAMIC CHIP
ELECT
CERAMIC CHIP
CERAMIC CHIP

0.1uF
0.01uF
10uF
0.0022uF
0.0022uF

10%
20%
10%
10%

25V
25V
50V
50V
50V

C532

1-162-966-11 CERAMIC CHIP

0.0022uF 10%

50V

20%
20%

50V
50V
50V
50V
25V

55

CX-JDS22/JDS33
MAIN
Ref. No.

Part No.

Description

C533
C534
C535
C536

1-107-826-11
1-162-960-11
1-162-966-11
1-162-966-11

CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP

0.1uF
220PF
0.0022uF
0.0022uF

10%
10%
10%
10%

16V
50V
50V
50V

Remark

C537
C538
C539
C541
C542

1-162-966-11
1-162-966-11
1-104-662-91
1-162-919-11
1-162-919-11

CERAMIC CHIP
CERAMIC CHIP
ELECT
CERAMIC CHIP
CERAMIC CHIP

0.0022uF
0.0022uF
22uF
22PF
22PF

10%
10%
20%
5%
5%

50V
50V
25V
50V
50V

C802
C803
C804
C853
C872

1-126-923-91
1-104-662-91
1-165-621-91
1-126-933-11
1-126-947-11

ELECT
ELECT
CERAMIC CHIP
ELECT
ELECT

220uF
22uF
0.1uF
100uF
47uF

20%
20%
20%
20%

10V
25V
50V
16V
35V

C873

1-126-963-11 ELECT

4.7uF

20%

50V

Ref. No.

Part No.

Description

Remark

< IC >
IC101
IC102
IC401

6-709-433-01 IC KIA7810API
6-702-771-01 IC TA78033LS
6-702-800-01 IC BD3882FV
< JACK >

J171

1-536-708-81 TERMINAL BOARD, PUSH (4P) (SPEAKER)

< JUMPER RESISTOR >

< CONNECTOR >

CN101
CN112
CN171
CNP501
CNP871

1-784-792-11
1-568-830-11
1-778-981-21
1-564-709-11
1-564-506-11

CONNECTOR, FFC 31P

CONNECTOR, FFC 11P
CONNECTOR, BOARD TO BOARD 13P
PIN, CONNECTOR (SMALL TYPE) 7P
PLUG, CONNECTOR 3P
< DIODE >

D101
D103
D104
D105
D106

6-500-360-01
6-501-046-01
6-501-046-01
6-501-046-01
6-501-046-01

DIODE
DIODE
DIODE
DIODE
DIODE

D10XB20 (JDS33)
1N5402-F46 (JDS22)
1N5402-F46 (JDS22)
1N5402-F46 (JDS22)
1N5402-F46 (JDS22)

D111
D112
D113
D114
D115

6-500-522-31
6-500-522-31
6-500-522-31
6-500-522-31
8-719-083-70

DIODE
DIODE
DIODE
DIODE
DIODE

10EDB40-TB5
10EDB40-TB5
10EDB40-TB5
10EDB40-TB5
UDZSTE-1727B

D116
D117
D118
D119
D120

8-719-000-07
6-500-522-31
6-500-522-31
6-500-522-31
8-719-988-61

DIODE
DIODE
DIODE
DIODE
DIODE

MC2836
10EDB40-TB5
10EDB40-TB5
10EDB40-TB5
1SS355TE-17

D124
D141
D152
D153
D154

6-500-522-31
8-719-083-57
6-500-335-01
6-500-335-01
6-500-335-01

DIODE
DIODE
DIODE
DIODE
DIODE

10EDB40-TB5
UDZSTE-173.6B
MC2838-T112-1
MC2838-T112-1
MC2838-T112-1

D155
D156
D157
D158
D401

8-719-000-07
8-719-000-07
8-719-000-07
6-500-848-01
8-719-083-60

DIODE
DIODE
DIODE
DIODE
DIODE

MC2836
MC2836
MC2836
MC2840-T112-1
UDZSTE-174.7B

D402
D502
D801
D871
D872

8-719-083-60
8-719-988-61
6-500-848-01
6-500-335-01
8-719-000-07

DIODE
DIODE
DIODE
DIODE
DIODE

UDZSTE-174.7B
1SS355TE-17
MC2840-T112-1
MC2838-T112-1
MC2836

< EARTH TERMINAL >

* EP101
* EP102

56

1-537-738-21 TERMINAL, EARTH

1-537-738-21 TERMINAL, EARTH

JR101
JR401
JR801
JR802

1-216-864-11
1-216-864-11
1-216-864-11
1-216-864-11

SHORT CHIP
SHORT CHIP
SHORT CHIP
SHORT CHIP

0
0
0
0

< COIL >

L171
L172
L501
L801
L802

1-422-009-13
1-422-009-13
1-456-094-11
1-216-864-11
1-216-864-11

COIL, AIR-CORE
COIL, AIR-CORE
TRANSFORMER, BIAS OSCILLATION
SHORT CHIP
0
SHORT CHIP
0
< TRANSISTOR >

Q101
Q102
Q151
Q152
Q153

8-729-119-76
8-729-120-28
8-729-120-28
8-729-600-22
8-729-120-28

TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR

2SA1175-HFE
2SC1623-L5L6
2SC1623-L5L6
2SA1235-F
2SC1623-L5L6

Q401
Q403
Q501
Q502
Q503

6-550-008-01
8-729-120-28
8-729-600-22
8-729-048-99
8-729-048-99

TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR

UM6K1N-TN
2SC1623-L5L6
2SA1235-F
2SK2541-T
2SK2541-T

Q504
Q505
Q506
Q507
Q508

8-729-048-99
8-729-120-28
8-729-120-28
8-729-620-05
8-729-620-05

TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR

2SK2541-T
2SC1623-L5L6
2SC1623-L5L6
2SC2603-EF
2SC2603-EF

Q509
Q510
Q801
Q803
Q871

8-729-037-03
8-729-027-56
8-729-024-43
8-729-120-28
8-729-120-28

TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR

KTA1266GR-AT
DTC143TKA-T146
2SA1365-T112-1EF
2SC1623-L5L6
2SC1623-L5L6

Q872
Q873
Q874

8-729-037-03 TRANSISTOR
8-729-120-28 TRANSISTOR
8-729-120-28 TRANSISTOR

KTA1266GR-AT
2SC1623-L5L6
2SC1623-L5L6

< RESISTOR >

R101
R102

1-216-837-11 METAL CHIP

1-216-833-11 METAL CHIP

22K
10K

5%
5%

R102

1-216-837-11 METAL CHIP

22K

5%

R103
R104

1-216-833-11 METAL CHIP

1-216-829-11 METAL CHIP

10K
4.7K

5%
5%

R105
R106

1-216-837-11 METAL CHIP

1-216-833-11 METAL CHIP

22K
10K

5%
5%

1/10W
1/10W
(JDS22)
1/10W
(JDS33)
1/10W
1/10W
1/10W
1/10W
(JDS22)

CX-JDS22/JDS33
MAIN
Ref. No.

Part No.

Description

Remark

R106

1-216-837-11 METAL CHIP

22K

5%

R107
R108

1-216-833-11 METAL CHIP

1-216-829-11 METAL CHIP

10K
4.7K

5%
5%

1/10W
(JDS33)
1/10W
1/10W

R109
R110
R111
R112
R113

1-216-837-11
1-216-825-11
1-216-833-11
1-216-829-11
1-216-837-11

METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP

22K
2.2K
10K
4.7K
22K

5%
5%
5%
5%
5%

1/10W
1/10W
1/10W
1/10W
1/10W

R114
R115
R116
R117
R118

1-216-825-11
1-216-833-11
1-216-829-11
1-216-829-11
1-216-821-11

METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP

2.2K
10K
4.7K
4.7K
1K

5%
5%
5%
5%
5%

1/10W
1/10W
1/10W
1/10W
1/10W

R119
R120
R121
R122
R123

1-216-797-11
1-216-825-11
1-260-292-11
1-216-817-11
1-216-813-11

METAL CHIP
METAL CHIP
CARBON
METAL CHIP
METAL CHIP

10
2.2K
1
470
220

5%
5%
5%
5%
5%

1/10W
1/10W
1/2W
1/10W
1/10W

R124
R125
R126
R127
R128

1-216-817-11
1-216-813-11
1-216-833-11
1-216-833-11
1-260-064-11

METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
CARBON

470
220
10K
10K
1

5%
5%
5%
5%
5%

1/10W
1/10W
1/10W
1/10W
1/2W

R129
R130
R131
R132
R133

1-216-845-11
1-216-837-11
1-216-841-11
1-216-849-11
1-259-296-11

METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
CARBON

100K
22K
47K
220K
470

5%
5%
5%
5%
5%

1/10W
1/10W
1/10W
1/10W
1/2W

R134
R135
R136
R137
R138

1-259-296-11
1-259-296-11
1-259-296-11
1-259-296-11
1-259-272-91

CARBON
CARBON
CARBON
CARBON
CARBON

470
470
470
470
47

5%
5%
5%
5%
5%

1/2W
1/2W
1/2W
1/2W
1/2W

R139
R140
R141
R142
R143

1-259-272-91
1-259-296-11
1-216-845-11
1-216-825-11
1-216-833-11

CARBON
CARBON
METAL CHIP
METAL CHIP
METAL CHIP

47
470
100K
2.2K
10K

5%
5%
5%
5%
5%

1/2W
1/2W
1/10W
1/10W
1/10W
(JDS22)

R143
R144

1-216-864-11 SHORT CHIP

1-216-833-11 METAL CHIP

0 (JDS33)
10K
5%

R144
R145
R146

1-216-864-11 SHORT CHIP

1-216-864-11 SHORT CHIP
1-216-864-11 SHORT CHIP

0 (JDS33)
0
0

R147
R148
R149

1-259-296-11 CARBON
1-259-296-11 CARBON
1-259-288-91 CARBON

470
470
220

5%
5%
5%

R149

1-259-296-11 CARBON

470

5%

R150

1-259-272-91 CARBON

47

5%

1/2W
1/2W
1/2W
(JDS22)
1/2W
(JDS33)
1/2W

R151
R152
R153
R154
R155

1-216-821-11
1-216-821-11
1-216-849-11
1-216-849-11
1-216-825-11

1K
1K
220K
220K
2.2K

5%
5%
5%
5%
5%

1/10W
1/10W
1/10W
1/10W
1/10W

METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP

1/10W
(JDS22)

Ref. No.

Part No.

Description

R156
R157
R158
R159
R160

1-216-825-11
1-216-821-11
1-216-821-11
1-216-825-11
1-216-825-11

METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP

2.2K
1K
1K
2.2K
2.2K

5%
5%
5%
5%
5%

1/10W
1/10W
1/10W
1/10W
1/10W

Remark

R161
R162
R163
R164
R165

1-216-841-11
1-216-809-11
1-216-841-11
1-216-809-11
1-216-809-11

METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP

47K
100
47K
100
100

5%
5%
5%
5%
5%

1/10W
1/10W
1/10W
1/10W
1/10W

R170
R171
R172
R173
R174

1-216-864-11
1-259-288-91
1-259-288-91
1-259-288-91
1-259-288-91

SHORT CHIP
CARBON
CARBON
CARBON
CARBON

0
220
220
220
220

5%
5%
5%
5%

1/2W
1/2W
1/2W
1/2W

R175
R179
R180
R181
R182

1-216-841-11
1-259-256-11
1-259-256-11
1-259-256-11
1-259-256-11

METAL CHIP
CARBON
CARBON
CARBON
CARBON

47K
10
10
10
10

5%
5%
5%
5%
5%

1/10W
1/2W
1/2W
1/2W
1/2W

R183
R184
R185

1-259-296-11 CARBON
1-259-296-11 CARBON
1-259-288-91 CARBON

470
470
220

5%
5%
5%

R185

1-259-296-11 CARBON

470

5%

R191

1-216-821-11 METAL CHIP

1K

5%

1/2W
1/2W
1/2W
(JDS22)
1/2W
(JDS33)
1/10W

R192
R195
R196
R405
R406

1-216-821-11
1-216-829-11
1-216-829-11
1-216-829-11
1-216-829-11

METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP

1K
4.7K
4.7K
4.7K
4.7K

5%
5%
5%
5%
5%

1/10W
1/10W
1/10W
1/10W
1/10W

R407
R408
R409
R410
R411

1-216-833-11
1-216-833-11
1-216-833-11
1-216-829-11
1-216-829-11

METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP

10K
10K
10K
4.7K
4.7K

5%
5%
5%
5%
5%

1/10W
1/10W
1/10W
1/10W
1/10W

R412
R413
R414
R415
R416

1-216-829-11
1-216-829-11
1-216-825-11
1-216-825-11
1-216-825-11

METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP

4.7K
4.7K
2.2K
2.2K
2.2K

5%
5%
5%
5%
5%

1/10W
1/10W
1/10W
1/10W
1/10W

R417
R418
R419
R420
R421

1-216-825-11
1-216-853-11
1-216-853-11
1-216-849-11
1-216-845-11

METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP

2.2K
470K
470K
220K
100K

5%
5%
5%
5%
5%

1/10W
1/10W
1/10W
1/10W
1/10W

R423
R424
R427
R428
R429

1-216-829-11
1-216-829-11
1-216-837-11
1-216-837-11
1-216-829-11

METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP

4.7K
4.7K
22K
22K
4.7K

5%
5%
5%
5%
5%

1/10W
1/10W
1/10W
1/10W
1/10W

R430
R433
R434
R437
R438

1-216-829-11
1-216-841-11
1-216-841-11
1-216-864-11
1-216-864-11

METAL CHIP
METAL CHIP
METAL CHIP
SHORT CHIP
SHORT CHIP

4.7K
47K
47K
0
0

5%
5%
5%

1/10W
1/10W
1/10W

R439

1-216-825-11 METAL CHIP

2.2K

5%

1/10W

57

CX-JDS22/JDS33
MAIN
Ref. No.

Part No.

Description

R440
R441
R442
R443

1-216-825-11
1-216-829-11
1-216-829-11
1-216-833-11

METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP

2.2K
4.7K
4.7K
10K

5%
5%
5%
5%

1/10W
1/10W
1/10W
1/10W

R444
R445
R446
R447
R448

1-216-833-11
1-216-864-11
1-216-864-11
1-216-825-11
1-216-825-11

METAL CHIP
SHORT CHIP
SHORT CHIP
METAL CHIP
METAL CHIP

10K
0
0
2.2K
2.2K

5%

1/10W

5%
5%

1/10W
1/10W

R449

1-216-821-11 METAL CHIP

1K

5%

1/10W
(JDS22)

R449
R450

1-216-864-11 SHORT CHIP

1-216-821-11 METAL CHIP

0 (JDS33)
1K
5%

R450
R471

1-216-864-11 SHORT CHIP

1-216-864-11 SHORT CHIP

0 (JDS33)
0

R479

1-216-809-11 METAL CHIP

100

5%

R479

1-216-825-11 METAL CHIP

2.2K

5%

R480

1-216-809-11 METAL CHIP

100

5%

R480

1-216-825-11 METAL CHIP

2.2K

5%

R481

1-164-315-11 CERAMIC CHIP

470PF

5%

1/10W
(JDS33)
1/10W
(JDS22)
1/10W
(JDS33)
1/10W
(JDS22)
50V

R482
R501
R502
R503
R504

1-164-315-11
1-216-841-11
1-216-849-11
1-216-849-11
1-216-829-11

CERAMIC CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP

470PF
47K
220K
220K
4.7K

5%
5%
5%
5%
5%

50V
1/10W
1/10W
1/10W
1/10W

R505
R506
R507
R508
R509

1-216-833-11
1-216-853-11
1-216-861-11
1-216-801-11
1-216-805-11

METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP

10K
470K
2.2M
22
47

5%
5%
5%
5%
5%

1/10W
1/10W
1/10W
1/10W
1/10W

R510
R511
R512
R513
R514

1-216-841-11
1-216-829-11
1-216-833-11
1-216-853-11
1-216-861-11

METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP

47K
4.7K
10K
470K
2.2M

5%
5%
5%
5%
5%

1/10W
1/10W
1/10W
1/10W
1/10W

R515
R516
R517
R518
R519

1-216-801-11
1-216-805-11
1-216-841-11
1-216-809-11
1-216-841-11

METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP

22
47
47K
100
47K

5%
5%
5%
5%
5%

1/10W
1/10W
1/10W
1/10W
1/10W

R520
R521
R522
R523
R524

1-216-809-11
1-216-841-11
1-216-801-11
1-216-837-11
1-216-821-11

METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP

100
47K
22
22K
1K

5%
5%
5%
5%
5%

1/10W
1/10W
1/10W
1/10W
1/10W

R525
R526
R527
R528
R529

1-216-825-11
1-216-825-11
1-216-837-11
1-216-821-11
1-216-825-11

METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP

2.2K
2.2K
22K
1K
2.2K

5%
5%
5%
5%
5%

1/10W
1/10W
1/10W
1/10W
1/10W

R530
R531
R532
R533

1-216-825-11
1-216-833-11
1-216-833-11
1-216-833-11

METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP

2.2K
10K
10K
10K

5%
5%
5%
5%

1/10W
1/10W
1/10W
1/10W

58

Remark

1/10W
(JDS22)

Ref. No.

Part No.

Description

Remark

R534

1-216-833-11 METAL CHIP

10K

5%

1/10W

R535
R536
R537
R538
R539

1-216-825-11
1-216-829-11
1-216-825-11
1-216-829-11
1-216-849-11

METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP

2.2K
4.7K
2.2K
4.7K
220K

5%
5%
5%
5%
5%

1/10W
1/10W
1/10W
1/10W
1/10W

R540
R542
R544
R545
R546

1-216-833-11
1-216-793-11
1-216-833-11
1-216-833-11
1-216-793-11

METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP

10K
4.7
10K
10K
4.7

5%
5%
5%
5%
5%

1/10W
1/10W
1/10W
1/10W
1/10W

R547
R548
R549
R550
R573

1-216-829-11
1-216-793-11
1-216-837-11
1-216-837-11
1-216-821-11

METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP

4.7K
4.7
22K
22K
1K

5%
5%
5%
5%
5%

1/10W
1/10W
1/10W
1/10W
1/10W

R574
R581
R582
R583
R801

1-216-821-11
1-216-845-11
1-216-833-11
1-216-825-11
1-216-833-11

METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP

1K
100K
10K
2.2K
10K

5%
5%
5%
5%
5%

1/10W
1/10W
1/10W
1/10W
1/10W

R803
R804
R805
R806
R807

1-216-864-11
1-216-837-11
1-216-821-11
1-216-821-11
1-216-829-11

SHORT CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP

0
22K
1K
1K
4.7K

5%
5%
5%
5%

1/10W
1/10W
1/10W
1/10W

R808
R809
R810
R811
R812

1-216-833-11
1-216-837-11
1-216-864-11
1-216-864-11
1-216-864-11

METAL CHIP
METAL CHIP
SHORT CHIP
SHORT CHIP
SHORT CHIP

10K
22K
0
0
0

5%
5%

1/10W
1/10W

R813
R814
R871
R872
R873

1-216-864-11
1-216-864-11
1-216-825-11
1-216-825-11
1-259-264-91

SHORT CHIP
SHORT CHIP
METAL CHIP
METAL CHIP
CARBON

0
0
2.2K
2.2K
22

5%
5%
5%

1/10W
1/10W
1/2W

R874
R875
R876
R877
R878

1-259-264-91
1-216-864-11
1-216-821-11
1-216-837-11
1-216-837-11

CARBON
SHORT CHIP
METAL CHIP
METAL CHIP
METAL CHIP

22
0
1K
22K
22K

5%

1/2W

5%
5%
5%

1/10W
1/10W
1/10W

R879
R880
R881
R882
R883

1-216-817-11
1-216-821-11
1-216-825-11
1-216-789-11
1-216-849-11

METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP

470
1K
2.2K
2.2
220K

5%
5%
5%
5%
5%

1/10W
1/10W
1/10W
1/10W
1/10W

R884
R885

1-216-801-11 METAL CHIP

1-216-789-11 METAL CHIP

22
2.2

5%
5%

1/10W
1/10W

< RELAY >

RY171

1-755-170-11 RELAY
< WIRE >

WH101 1-816-818-11 HLDER, WIRE 5P

WH102 1-817-362-11 HOLDER, WIRE 7P
*************************************************************

CX-JDS22/JDS33
PAI/HP/MIC
Ref. No.

Part No.

Description

Remark

A-1115-978-A PAI/HP/MIC BOARD, COMPLETE (JDS33)

A-1115-979-A PAI/HP/MIC BOARD, COMPLETE (JDS22)
**************************
< CAPACITOR >
C550
C551
C552
C553
C554

1-126-514-11
1-115-871-11
1-162-962-11
1-115-868-11
1-115-467-11

ELECT
ELECT
CERAMIC CHIP
ELECT
CERAMIC CHIP

22uF
1uF
470PF
0.22uF
0.22uF

20%
20%
10%
20%
10%

16V
50V
50V
50V
10V

C555
C556
C557
C558
C559

1-164-816-11
1-164-315-11
1-126-176-11
1-126-382-11
1-164-156-11

CERAMIC CHIP
CERAMIC CHIP
ELECT
ELECT
CERAMIC CHIP

220PF
470PF
220uF
100uF
0.1uF

2%
5%
20%
20%

50V
50V
10V
16V
25V

C560
C561
C562
C563
C564

1-164-156-11
1-164-156-11
1-162-927-11
1-162-974-11
1-162-974-11

CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP

0.1uF
0.1uF
100PF
0.01uF
0.01uF

C565
C566
C567
C568
C569

1-164-156-11
1-164-156-11
1-164-156-11
1-164-156-11
1-164-156-11

CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP

0.1uF
0.1uF
0.1uF
0.1uF
0.1uF

5%

25V
25V
50V
50V
50V
25V
25V
25V
25V
25V

5%
5%

1/10W
1/10W

R556
R557
R558
R559
R560

1-216-825-11
1-216-829-11
1-216-825-11
1-216-845-11
1-216-825-11

METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP

2.2K
4.7K
2.2K
100K
2.2K

5%
5%
5%
5%
5%

1/10W
1/10W
1/10W
1/10W
1/10W

R561
R562
R563
R564
R565

1-216-849-11
1-216-841-11
1-216-841-11
1-216-849-11
1-216-825-11

METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP

220K
47K
47K
220K
2.2K

5%
5%
5%
5%
5%

1/10W
1/10W
1/10W
1/10W
1/10W

R566
R567
R568
R569
R570

1-216-829-11
1-216-829-11
1-216-845-11
1-216-841-11
1-216-853-11

METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP

4.7K
4.7K
100K
47K
470K

5%
5%
5%
5%
5%

1/10W
1/10W
1/10W
1/10W
1/10W

R571
R572
R575
R576
R580

1-216-857-11
1-216-809-11
1-216-837-11
1-216-837-11
1-216-813-11

METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP

1M
100
22K
22K
220

5%
5%
5%
5%
5%

1/10W
1/10W
1/10W
1/10W
1/10W

< VARIABLE RESISTOR >

A-1101-540-A PANEL BOARD, COMPLETE

(including CONTACT BOARD) (JDS33: E51)
A-1101-542-A PANEL BOARD, COMPLETE
(including CONTACT BOARD) (JDS33: MX)
A-1101-564-A PANEL BOARD, COMPLETE
(including CONTACT BOARD) (JDS22: E51)
A-1101-566-A PANEL BOARD, COMPLETE
(including CONTACT BOARD) (JDS22: MX)
**********************

1-537-738-21 TERMINAL, EARTH

1-537-738-21 TERMINAL, EARTH

6-702-457-01 IC NJM14558M-TE2

1-794-702-11
1-794-702-11
1-770-226-11
1-770-226-11

JACK, HEADPHONE (PHONES)

JACK, HEADPHONE (AUDIO IN)
JACK (LARGE TYPE) (MIC 1)
JACK (LARGE TYPE) (MIC 2)

2-515-247-01 GUIDE, FL
< CAPACITOR >
C600
C601
C602
C603
C604

1-162-964-11
1-126-916-11
1-164-156-11
1-165-621-91
1-164-156-11

CERAMIC CHIP
ELECT
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP

0.001uF
1000uF
0.1uF
0.1uF
0.1uF

10%
20%

50V
6.3V
25V
50V
25V

C605
C606
C607
C608
C609

1-126-933-11
1-107-826-11
1-162-919-11
1-162-919-11
1-165-176-11

ELECT
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP

100uF
0.1uF
22PF
22PF
0.047uF

20%
10%
5%
5%
10%

16V
16V
50V
50V
16V

2SK2541-T
2SC1623-L5L6

C610
C611
C612
C613
C614

1-164-230-11
1-126-965-11
1-164-230-11
1-164-230-11
1-126-960-11

CERAMIC CHIP
ELECT
CERAMIC CHIP
CERAMIC CHIP
ELECT

220PF
22uF
220PF
220PF
1uF

5%
20%
5%
5%
20%

50V
50V
50V
50V
50V

47
47
4.7K

C615
C616
C618
C619
C620

1-126-960-11
1-126-965-11
1-162-923-11
1-162-923-11
1-162-923-11

ELECT
ELECT
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP

1uF
22uF
47PF
47PF
47PF

20%
20%
5%
5%
5%

50V
50V
50V
50V
50V

< JUMPER RESISTOR >

JR502
JR503
JR551
JR552

1-216-864-11
1-216-864-11
1-216-864-11
1-216-864-11

SHORT CHIP
SHORT CHIP
SHORT CHIP
SHORT CHIP

0
0
0
0

< COIL >

L551
L552
L553

1-216-864-11 SHORT CHIP

0
1-216-864-11 SHORT CHIP
0
1-469-152-11 FERRITE, EMI (SMD) (2012)
< TRANSISTOR >

Q551
Q552

8-729-048-99 TRANSISTOR
8-729-120-28 TRANSISTOR
< RESISTOR >

R551
R552
R553

1-259-272-91 CARBON
1-259-272-91 CARBON
1-216-829-11 METAL CHIP

Remark
4.7K
4.7K

< JACK >

J551
J552
J553
J554

Description

1-216-829-11 METAL CHIP

1-216-829-11 METAL CHIP

< IC >
IC551

Part No.

R554
R555

VR501 1-223-983-11 RES, VAR, CARBON

50K (MIC LEVEL)
*************************************************************

< EARTH TERMINAL >

* EP501
* EP502

Ref. No.

PANEL

5%
5%
5%

1/2W
1/2W
1/10W

59

CX-JDS22/JDS33
PANEL
Ref. No.

Part No.

Description

Remark

Ref. No.

Part No.

Description

Remark

< CONNECTOR >

C621
C622
C623
C624
C625

1-164-230-11
1-162-923-11
1-162-968-11
1-162-968-11
1-164-227-11

CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP

220PF
47PF
0.0047uF
0.0047uF
0.022uF

5%
5%
10%
10%
10%

50V
50V
50V
50V
25V

C628
C629
C630
C631
C632

1-162-923-11
1-164-156-11
1-162-923-11
1-107-826-11
1-162-923-11

CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP

47PF
0.1uF
47PF
0.1uF
47PF

5%
5%
10%
5%

50V
25V
50V
16V
50V

C633
C634
C635
C636
C637

1-162-970-11
1-162-964-11
1-164-230-11
1-126-916-11
1-162-907-11

CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
ELECT
CERAMIC CHIP

0.01uF
0.001uF
220PF
1000uF
2PF

10%
10%
5%
20%
0.25PF

25V
50V
50V
6.3V
50V

C638
C639
C640
C642
C643

1-162-964-11
1-164-230-11
1-162-962-11
1-164-156-11
1-162-923-11

CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP

0.001uF
220PF
470PF
0.1uF
47PF

10%
5%
10%
5%

50V
50V
50V
25V
50V

C644
C645
C646
C647
C648

1-164-156-11
1-162-919-11
1-162-919-11
1-162-919-11
1-162-919-11

CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP

0.1uF
22PF
22PF
22PF
22PF

5%
5%
5%
5%

25V
50V
50V
50V
50V

C649
C650
C651
C652
C653

1-162-919-11
1-126-965-11
1-126-964-11
1-126-965-11
1-126-964-11

CERAMIC CHIP
ELECT
ELECT
ELECT
ELECT

22PF
22uF
10uF
22uF
10uF

5%
20%
20%
20%
20%

50V
50V
50V
50V
50V

C654
C655
C656
C657
C658

1-164-230-11
1-164-230-11
1-162-923-11
1-162-923-11
1-164-156-11

CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP

220PF
220PF
47PF
47PF
0.1uF

5%
5%
5%
5%

50V
50V
50V
50V
25V

C659
C660
C661
C662
C663

1-162-964-11
1-162-964-11
1-164-230-11
1-162-923-11
1-164-156-11

CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP

0.001uF
0.001uF
220PF
47PF
0.1uF

10%
10%
5%
5%

50V
50V
50V
50V
25V

C664
C665
C666
C667
C668

1-164-156-11
1-164-156-11
1-162-964-11
1-162-927-11
1-162-927-11

CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP

0.1uF
0.1uF
0.001uF
100PF
100PF

C669
C670

1-162-927-11 CERAMIC CHIP

1-164-156-11 CERAMIC CHIP

C670

1-165-176-11 CERAMIC CHIP

C671
C674

1-164-156-11 CERAMIC CHIP

1-162-927-11 CERAMIC CHIP

50V
25V
(JDS22: MX)
0.047uF 10%
16V
(JDS22: E51/JDS33)
0.1uF
25V
100PF
5%
50V

C676
C677
C678
C680
C682

1-164-156-11
1-216-864-11
1-216-864-11
1-126-382-11
1-162-960-11

0.1uF
0
0
100uF
220PF

100PF
0.1uF

10%
5%
5%

25V
25V
50V
50V
50V

5%

CN601
CN602
CN604
CN651
CN699

1-784-753-11
1-779-295-11
1-784-735-11
(Not supplied)
1-784-731-11

CONNECTOR, FFC 31P

CONNECTOR, FFC (LIF (NON-ZIF)) 27P
CONNECTOR, FFC 13P
PIN, CONNECTOR (SMALL TYPE) 11P
CONNECTOR, FFC 9P
< DIODE >

D601
D602
D603
D604
D605

8-719-977-28
8-719-000-07
8-719-000-07
8-719-988-61
8-719-988-61

DIODE
DIODE
DIODE
DIODE
DIODE

DTZ10B
MC2836
MC2836
1SS355TE-17
1SS355TE-17

D607
D665

6-500-848-01 DIODE MC2840-T112-1

8-719-988-61 DIODE 1SS355TE-17
< EARTH TERMINAL >

* EP601

1-537-738-21 TERMINAL, EARTH

< FLUORESCENT INDICATOR TUBE >

FL601

1-519-820-11 INDICATOR TUBE, FLUORESCENT

< IC >

IC601
IC602
IC603
IC604
IC605

8-759-643-83
6-600-446-01
8-759-713-61
6-806-016-01
6-704-135-01

IC
IC
IC
IC
IC

uPD16315GB-3BS
RPM7240-H18
PST3429UL
M30302MCP-A07FPU0
MM1614A

< JUMPER RESISTOR >

JR601
JR604
JR605
JR607
JR608

1-216-864-11
1-216-864-11
1-216-864-11
1-216-864-11
1-216-864-11

SHORT CHIP
SHORT CHIP
SHORT CHIP
SHORT CHIP
SHORT CHIP

0
0 (JDS22)
0
0
0

< COIL >

L602
L603
L604
L605
L606

1-469-152-11
1-216-864-11
1-216-864-11
1-216-864-11
1-216-864-11

FERRITE, EMI (SMD) (2012)

SHORT CHIP
0
SHORT CHIP
0
SHORT CHIP
0
SHORT CHIP
0

L607
L608
L609
L610
L611

1-216-864-11
1-216-864-11
1-216-864-11
1-216-864-11
1-469-152-11

SHORT CHIP
0
SHORT CHIP
0
SHORT CHIP
0
SHORT CHIP
0
FERRITE, EMI (SMD) (2012)
< LED >

LED607 8-719-063-93 DIODE SLR325VC-N-T32 (STAND BY)

LED608 6-500-641-01 DIODE SLI-325URC (i-Bass)
< TRANSISTOR >

60

CERAMIC CHIP
SHORT CHIP
SHORT CHIP
ELECT
CERAMIC CHIP

25V

20%
10%

16V
50V

Q604
Q605
Q606
Q607
Q608

1-801-806-11
8-729-120-28
1-801-806-11
1-801-806-11
8-729-120-28

TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR

DTC144EKA
2SC1623-L5L6
DTC144EKA
DTC144EKA
2SC1623-L5L6

CX-JDS22/JDS33
PANEL
Ref. No.

Part No.

Description

Remark

Q609
Q610
Q611
Q612
Q613

8-729-120-28
8-729-120-28
8-729-024-43
8-729-024-43
8-729-120-28

TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR

2SC1623-L5L6
2SC1623-L5L6
2SA1365-T112-1EF
2SA1365-T112-1EF
2SC1623-L5L6

Q614
Q615
Q616
Q617
Q618

8-729-120-28
8-729-120-28
8-729-120-28
8-729-120-28
1-801-806-11

TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR

Q619
Q620
Q621
Q622
Q623

8-729-600-22
8-729-120-28
8-729-024-43
8-729-047-62
8-729-024-43

Q624
Q625
Q626
Q627
Q628
Q629
Q630
Q631
Q632

Ref. No.

Part No.

Description

Remark

R630
R631
R632
R633
R634

1-216-809-11
1-216-809-11
1-216-833-11
1-216-837-11
1-216-809-11

METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP

100
100
10K
22K
100

5%
5%
5%
5%
5%

1/10W
1/10W
1/10W
1/10W
1/10W

2SC1623-L5L6
2SC1623-L5L6
2SC1623-L5L6
2SC1623-L5L6
DTC144EKA

R635
R636
R637
R638
R639

1-216-821-11
1-216-833-11
1-216-809-11
1-216-813-11
1-216-809-11

METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP

1K
10K
100
220
100

5%
5%
5%
5%
5%

1/10W
1/10W
1/10W
1/10W
1/10W

TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR

2SA1235-F
2SC1623-L5L6
2SA1365-T112-1EF
2SC3440-T12-1F
2SA1365-T112-1EF

R640
R641
R642
R643
R644

1-216-864-11
1-216-833-11
1-216-809-11
1-216-809-11
1-216-821-11

SHORT CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP

0
10K
100
100
1K

5%
5%
5%
5%

1/10W
1/10W
1/10W
1/10W

8-729-047-62
8-729-600-22
8-729-040-76
8-729-024-43
8-729-047-62

TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR

2SC3440-T12-1F
2SA1235-F
KTA1273-Y-AT
2SA1365-T112-1EF
2SC3440-T12-1F

R645
R646
R647
R648
R649

1-216-841-11
1-216-821-11
1-216-841-11
1-216-809-11
1-216-845-11

METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP

47K
1K
47K
100
100K

5%
5%
5%
5%
5%

1/10W
1/10W
1/10W
1/10W
1/10W

8-729-024-43
8-729-119-76
8-729-047-62
8-729-120-28

TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR

2SA1365-T112-1EF
2SA1175-HFE
2SC3440-T12-1F
2SC1623-L5L6

R650
R651
R652
R653
R654

1-216-833-11
1-216-821-11
1-216-817-11
1-216-817-11
1-216-821-11

METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP

10K
1K
470
470
1K

5%
5%
5%
5%
5%

1/10W
1/10W
1/10W
1/10W
1/10W

R655
R656

1-216-821-11 METAL CHIP

1-216-821-11 METAL CHIP

1K
1K

5%
5%

R657
R658
R659

1-216-821-11 METAL CHIP

1-216-821-11 METAL CHIP
1-216-821-11 METAL CHIP

1K
1K
1K

5%
5%
5%

1/10W
1/10W
(JDS33)
1/10W
1/10W
1/10W

R660
R661
R662
R663
R664

1-216-821-11
1-216-837-11
1-216-821-11
1-216-821-11
1-216-817-11

METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP

1K
22K
1K
1K
470

5%
5%
5%
5%
5%

1/10W
1/10W
1/10W
1/10W
1/10W

R665
R666
R667
R668
R669

1-216-841-11
1-216-817-11
1-216-841-11
1-216-817-11
1-216-841-11

METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP

47K
470
47K
470
47K

5%
5%
5%
5%
5%

1/10W
1/10W
1/10W
1/10W
1/10W

R670
R671
R672
R673
R675

1-216-817-11
1-216-841-11
1-218-446-11
1-218-446-11
1-216-817-11

METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP

470
47K
1
1
470

5%
5%
5%
5%
5%

1/10W
1/10W
1/10W
1/10W
1/10W

R676
R677
R678
R679
R680

1-216-821-11
1-216-821-11
1-216-821-11
1-216-821-11
1-216-864-11

METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
SHORT CHIP

1K
1K
1K
1K
0

5%
5%
5%
5%

1/10W
1/10W
1/10W
1/10W

R681
R682
R683
R684
R685

1-216-821-11
1-216-837-11
1-216-837-11
1-216-837-11
1-216-837-11

METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP

1K
22K
22K
22K
22K

5%
5%
5%
5%
5%

1/10W
1/10W
1/10W
1/10W
1/10W

R686

1-216-837-11 METAL CHIP

22K

5%

1/10W

< RESISTOR >

R601
R602
R603
R604
R605

1-216-864-11
1-216-845-11
1-216-849-11
1-216-845-11
1-216-853-11

SHORT CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP

0
100K
220K
100K
470K

5%
5%
5%
5%

1/10W
1/10W
1/10W
1/10W

R606
R607
R608
R609

1-216-833-11
1-216-845-11
1-219-570-11
1-216-829-11

METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP

10K
100K
10M
4.7K

5%
5%
5%
5%

R609

1-216-833-11 METAL CHIP

10K

5%

1/10W
1/10W
1/10W
1/10W
(JDS33)
1/10W
(JDS22)

R610
R611
R612
R613
R614

1-216-833-11
1-216-809-11
1-216-809-11
1-216-809-11
1-216-864-11

METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
SHORT CHIP

10K
100
100
100
0

5%
5%
5%
5%

1/10W
1/10W
1/10W
1/10W

R615
R616
R617
R618
R619

1-216-864-11
1-218-446-11
1-216-821-11
1-216-809-11
1-216-821-11

SHORT CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP

0
1
1K
100
1K

5%
5%
5%
5%

1/10W
1/10W
1/10W
1/10W

R620
R621
R622
R623
R624

1-216-821-11
1-216-821-11
1-216-821-11
1-216-817-11
1-216-817-11

METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP

1K
1K
1K
470
470

5%
5%
5%
5%
5%

1/10W
1/10W
1/10W
1/10W
1/10W

R625
R626
R627
R628
R629

1-216-821-11
1-216-825-11
1-216-825-11
1-216-809-11
1-216-821-11

METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP

1K
2.2K
2.2K
100
1K

5%
5%
5%
5%
5%

1/10W
1/10W
1/10W
1/10W
1/10W

61

CX-JDS22/JDS33
PANEL
Ref. No.

Part No.

Description

R687
R689
R690
R691

1-216-837-11
1-216-821-11
1-216-821-11
1-216-857-11

METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP

22K
1K
1K
1M

5%
5%
5%
5%

1/10W
1/10W
1/10W
1/10W

R692
R693
R695
R696
R698

1-216-845-11
1-216-809-11
1-216-845-11
1-216-821-11
1-216-833-11

METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP

100K
100
100K
1K
10K

5%
5%
5%
5%
5%

1/10W
1/10W
1/10W
1/10W
1/10W

R701
R702
R703
R704
R705

1-216-841-11
1-216-817-11
1-216-817-11
1-216-841-11
1-216-841-11

METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP

47K
470
470
47K
47K

5%
5%
5%
5%
5%

1/10W
1/10W
1/10W
1/10W
1/10W

R706
R707
R708
R709
R710

1-216-817-11
1-216-841-11
1-216-817-11
1-216-837-11
1-216-837-11

METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP

470
47K
470
22K
22K

5%
5%
5%
5%
5%

1/10W
1/10W
1/10W
1/10W
1/10W

R712
R713
R715
R716
R717

1-216-837-11
1-216-833-11
1-216-825-11
1-216-825-11
1-216-825-11

METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP

22K
10K
2.2K
2.2K
2.2K

5%
5%
5%
5%
5%

1/10W
1/10W
1/10W
1/10W
1/10W

R720
R721
R722
R723
R724

1-216-833-11
1-216-817-11
1-216-833-11
1-216-833-11
1-216-837-11

METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP

10K
470
10K
10K
22K

5%
5%
5%
5%
5%

1/10W
1/10W
1/10W
1/10W
1/10W

R725
R726
R727
R728
R729

1-216-825-11
1-216-837-11
1-216-837-11
1-216-837-11
1-216-833-11

METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP

2.2K
22K
22K
22K
10K

5%
5%
5%
5%
5%

1/10W
1/10W
1/10W
1/10W
1/10W

R730
R731
R732
R733
R734

1-216-821-11
1-216-837-11
1-216-833-11
1-216-821-11
1-216-821-11

METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP

1K
22K
10K
1K
1K

5%
5%
5%
5%
5%

1/10W
1/10W
1/10W
1/10W
1/10W

R735
R736
R737
R738
R739

1-216-821-11
1-216-845-11
1-216-845-11
1-216-821-11
1-216-825-11

METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP

1K
100K
100K
1K
2.2K

5%
5%
5%
5%
5%

1/10W
1/10W
1/10W
1/10W
1/10W

R740
R741
R742
R743
R744

1-216-829-11
1-216-833-11
1-216-825-11
1-216-841-11
1-216-849-11

METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP

4.7K
10K
2.2K
47K
220K

5%
5%
5%
5%
5%

1/10W
1/10W
1/10W
1/10W
1/10W

R745
R757
R758
R759
R760

1-216-841-11
1-216-817-11
1-216-809-11
1-216-821-11
1-216-821-11

METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP

47K
470
100
1K
1K

5%
5%
5%
5%
5%

1/10W
1/10W
1/10W
1/10W
1/10W

R761
R762
R763
R764

1-216-825-11
1-216-825-11
1-216-829-11
1-216-833-11

METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP

2.2K
2.2K
4.7K
10K

5%
5%
5%
5%

1/10W
1/10W
1/10W
1/10W

62

Remark

Ref. No.

Part No.

Description

Remark

R765

1-216-837-11 METAL CHIP

22K

5%

1/10W

R766
R767
R768
R769
R770

1-216-833-11
1-216-817-11
1-216-809-11
1-216-821-11
1-216-821-11

METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP

10K
470
100
1K
1K

5%
5%
5%
5%
5%

1/10W
1/10W
1/10W
1/10W
1/10W

R771
R772
R773
R774
R775

1-216-825-11
1-216-825-11
1-216-829-11
1-216-833-11
1-216-837-11

METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP

2.2K
2.2K
4.7K
10K
22K

5%
5%
5%
5%
5%

1/10W
1/10W
1/10W
1/10W
1/10W

R776
R777
R778
R779
R780

1-216-841-11
1-216-837-11
1-216-837-11
1-216-833-11
1-216-837-11

METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP

47K
22K
22K
10K
22K

5%
5%
5%
5%
5%

1/10W
1/10W
1/10W
1/10W
1/10W

R781
R782
R786
R787
R788

1-216-837-11
1-216-833-11
1-216-833-11
1-216-817-11
1-216-809-11

METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP

22K
10K
10K
470
100

5%
5%
5%
5%
5%

1/10W
1/10W
1/10W
1/10W
1/10W

R789
R790
R791
R792
R793

1-216-821-11
1-216-821-11
1-216-825-11
1-216-825-11
1-216-829-11

METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP

1K
1K
2.2K
2.2K
4.7K

5%
5%
5%
5%
5%

1/10W
1/10W
1/10W
1/10W
1/10W

R794
R795
R796
R797
R801

1-216-833-11
1-216-837-11
1-216-837-11
1-216-817-11
1-216-837-11

METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP

10K
22K
22K
470
22K

5%
5%
5%
5%
5%

1/10W
1/10W
1/10W
1/10W
1/10W

R802
R803
R804
R805
R806

1-216-837-11
1-216-837-11
1-216-833-11
1-216-825-11
1-216-829-11

METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP

22K
22K
10K
2.2K
4.7K

5%
5%
5%
5%
5%

1/10W
1/10W
1/10W
1/10W
1/10W

< SWITCH >

S601
S602
S603
S604
S605

1-771-410-21
1-771-410-21
1-771-410-21
1-771-410-21
1-771-410-21

SWITCH, TACTILE (?/1)

SWITCH, TACTILE (DISC 1)
SWITCH, TACTILE (DISC 2)
SWITCH, TACTILE (DISC 3)
SWITCH, TACTILE (DISC SKIP/EX-CHANGE)

S606
S607
S608
S609
S611

1-771-410-21
1-771-410-21
1-771-410-21
1-771-410-21
1-771-410-21

SWITCH, TACTILE (JDS22:N/JDS33:nN)

SWITCH, TACTILE (X)
SWITCH, TACTILE (ML/TUNING +)
SWITCH, TACTILE (REC PAUSE/START)
SWITCH, TACTILE (DISPLAY)

S612
S613
S614
S615
S616

1-771-410-21
1-771-410-21
1-771-410-21
1-771-410-21
1-771-410-21

SWITCH, TACTILE (BASS )

SWITCH, TACTILE (BASS +)
SWITCH, TACTILE (MIDDLE )
SWITCH, TACTILE (MIDDLE +)
SWITCH, TACTILE (TREBLE )

S617
S618
S619
S621
S622

1-771-410-21
1-771-410-21
1-771-410-21
1-771-410-21
1-771-410-21

SWITCH, TACTILE (TREBLE +)

SWITCH, TACTILE (i-Bass)
SWITCH, TACTILE (A)
SWITCH, TACTILE (x/CANCEL)
SWITCH, TACTILE (lm/TUNING )

CX-JDS22/JDS33
PANEL
Ref. No.

Part No.

Description

Remark

Ref. No.

Part No.

POWER

VOLUME

Description

Remark

WH002 1-817-362-11 HOLDER, WIRE 7P

*************************************************************

S623
S624
S625
S626
S627

1-771-410-21
1-771-410-21
1-771-410-21
1-771-410-21
1-771-410-21

SWITCH, TACTILE (CD SYNC)

SWITCH, TACTILE (TUNER/BAND)
SWITCH, TACTILE (EQ)
SWITCH, TACTILE (REP/FM MODE)
SWITCH, TACTILE (ENTER)

S628

1-771-410-21 SWITCH, TACTILE

S629
S651

(PLAY MODE/TUNING MODE)

1-771-410-21 SWITCH, TACTILE (FUNCTION)
1-786-418-11 SWITCH, ROTARY (ENCODER) (
+)

A-1115-980-A VOLUME BOARD, COMPLETE (JDS33)

A-1115-981-A VOLUME BOARD, COMPLETE (JDS22)
************************
< CONNECTOR >
CN652

1-819-803-11 CONNECTOR 11P

< LED >

< VIBRATOR >

X601
1-579-463-11 VIBRATOR, CRYSTAL (32.768kHz)
X602
1-795-482-11 VIBRATOR, CERAMIC (16MHz)
*************************************************************
A-1134-288-A
A-1134-289-A
A-1134-296-A
A-1134-297-A

POWER BOARD, COMPLETE (JDS33: E51)

POWER BOARD, COMPLETE (JDS33: MX)
POWER BOARD, COMPLETE (JDS22: E51)
POWER BOARD, COMPLETE (JDS22: MX)
***********************
< CAPACITOR >

C004
C005
C011

1-126-935-11 ELECT
1-164-156-11 CERAMIC CHIP
1-124-250-11 ELECT

C011

1-126-957-11 ELECT

470uF
0.1uF
0.15uF

20%

16V
25V
20%
50V
(JDS22: MX)
0.22uF
20%
50V
(JDS22: E51/JDS33)

LED601
LED602
LED603
LED604
LED605

6-500-641-01
6-500-641-01
6-500-641-01
6-500-641-01
6-500-641-01

DIODE
DIODE
DIODE
DIODE
DIODE

SLI-325URC (ILLUMINATION LED)

SLI-325URC (ILLUMINATION LED)
SLI-325URC (ILLUMINATION LED)
SLI-325URC (ILLUMINATION LED)
SLI-325URC (ILLUMINATION LED)

LED606 6-500-641-01 DIODE SLI-325URC (ILLUMINATION LED)

< RESISTOR >
R718
R719
R720
R746
R747

1-216-805-11
1-216-817-11
1-216-817-11
1-216-841-11
1-216-829-11

METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP

47
470
470
47K
4.7K

5%
5%
5%
5%
5%

1/10W
1/10W
1/10W
1/10W
1/10W

R748
R749
R750
R751
R752

1-216-833-11
1-216-821-11
1-216-825-11
1-216-849-11
1-216-841-11

METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP

10K
1K
2.2K
220K
47K

5%
5%
5%
5%
5%

1/10W
1/10W
1/10W
1/10W
1/10W

R753
R754
R755
R756
R783

1-216-825-11
1-216-817-11
1-216-805-11
1-216-805-11
1-216-817-11

METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP

2.2K
470
47
47
470

5%
5%
5%
5%
5%

1/10W
1/10W
1/10W
1/10W
1/10W

R784
R785
R798
R799
R800

1-216-805-11
1-216-805-11
1-216-805-11
1-216-817-11
1-216-817-11

METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP

47
47
47
470
470

5%
5%
5%
5%
5%

1/10W
1/10W
1/10W
1/10W
1/10W

< CONNECTOR >

CN001

1-564-321-00 PIN, CONNECTOR (3.96mm PITCH) 2P (MX)

< DIODE >

D001
D002
D003

8-719-000-07 DIODE MC2836

6-500-335-01 DIODE MC2838-T112-1
6-500-335-01 DIODE MC2838-T112-1
< TRANSFORMER >

0 PT003
0 PT004

1-439-944-11 TRANSFORMER, POWER (MX)

1-439-736-11 TRANSFORMER, POWER (E51)

< SWITCH >

S652
1-786-417-11 ENCODER, ROTARY (VOLUME)
*************************************************************

< RESISTOR >

R011
R012
R013
R014

1-216-821-11
1-216-821-11
1-216-837-11
1-216-809-11

METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP

1K
1K
22K
100

5%
5%
5%
5%

1/10W
1/10W
1/10W
1/10W

< RELAY >

0 RY001
0 RY002

1-755-276-11 RELAY, POWER (MX)

1-755-496-11 RELAY (E51)

MISCELLANEOUS
**************
67
74
74
82
0 106

1-832-038-11 CABLE, FLEXIBLE FLAT (27 CORE)

1-796-351-51 MECHANISM, SIGNAL CASSETTE
(CMAL1Z240A) (JDS33)
1-796-352-41 DECK, MECHANICAL (CMAL5Z220A) (JDS22)
1-469-854-11 CORE, FERRITE
1-827-226-31 CORD, POWER (MX)

0 106
111
112
113
113

1-830-384-11
1-831-778-11
1-831-782-11
1-831-761-11
1-831-767-11

< SWITCH >

0 S001

1-786-408-11 SELECTOR, VOLTAGE (SWS-2301)

(VOLTAGE SELECTOR) (E51)
< WIRE >

CORD, POWER (E51)

CABLE, FLEXIBLE FLAT (11 CORE)
CABLE, FLEXIBLE FLAT (11 CORE)
CABLE, FLEXIBLE FLAT (7 CORE) (JDS22)
CABLE, FLEXIBLE FLAT (8 CORE) (JDS33)

WH001 1-816-818-11 HLDER, WIRE 5P

63

CX-JDS22/JDS33

Ref. No.

Part No.

Description

0 114
0 157
158
161
162

1-569-008-21
8-820-244-01
1-827-992-11
1-828-400-51
1-831-938-11

ADAPTOR, CONVERSION 2P (E51)

OPTICAL PICK-UP (KSM-215DCP/C2NP)
WIRE (FLAT TYPE) (16 CORE)
WIRE (FLAT TYPE) (27 CORE)
CABLE, FLEXIBLE FLAT (13 CORE)

201
M871
0 PT001
0 PT001
0 PT002

1-797-193-12
1-787-344-11
1-443-722-11
1-443-723-11
1-443-700-11

MECHANICAL, CD
FAN, DC
TRANSFORMER, POWER (JDS33: MX)
TRANSFORMER, POWER (JDS22: MX)
TRANSFORMER, POWER (JDS33: E51)

0 PT002
S101
TU803

1-443-702-11 TRANSFORMER, POWER (JDS22: E51)

1-771-853-11 SWITCH, DETECTION (LIMIT)
1-693-628-11 TUNER (FM/AM)

64

Remark

CX-JDS22/JDS33

MEMO

65

CX-JDS22/JDS33

REVISION HISTORY
Clicking the version allows you to jump to the revised page.
Also, clicking the version at the upper right on the revised page allows you to jump to the next revised
page.
Ver.

Date

1.0

2006.02

Description of Revision
New