HCD-GNX660

SERVICE MANUAL

Mexican Model

Ver. 1.2 2007.12

HCD-GNX660 is the Amplifier,

CD player, tape deck and tuner
section in MHC-GNX660.

CD
Section

TAPE
Section

Model Name Using Similar Mechanism

HCD-GNX880

CD Mechanism Type

CDM74KFS-F1BD84

Base Unit Name

BU-F1BD84

Optical Pick-up Name

KSM-215DCP/C2NP

Model Name Using Similar Mechanism

HCD-GNX880

Tape Transport Mechanism Type

CWN42FF601

SPECIFICATIONS
Amplifier section
The following are measured at
Front speakers
DIN power output (rated)

127 V AC, 60 Hz

130 + 130 watts

(6 ohms at 1 kHz, DIN)
Continuous RMS power output (reference)
160 + 160 watts
(6 ohms at 1 kHz, 10% THD)
Sub woofer
Continuous RMS power output (reference)
200 watts
(4 ohms at 100 Hz, 10% THD)
TV (AUDIO) IN (phono jack)
voltage 250 mV,
impedance 47 kiloohms
MIC (phone jack)
sensitivity 1 mV,
impedance 10 kiloohm
VIDEO OUT (phono jack)
max. output level
1 Vp-p, unbalanced, Sync
negative, load impedance
75 ohms
PHONES (stereo mini jack)
accepts headphones o
8 ohms or more
FRONT SPEAKER/SUB WOOFER OUT
Use only the supplied
speaker

Disc player section

System
Laser

Laser Output

Frequency response
Wave length
Signal-to-noise ratio
Dynamic range
Tape deck section
Recording system
Frequency response

Compact disc and digital

audio system
Semiconductor laser
(=780 nm)
Emission duration:
continuous
Max. 44.6 W*
* This output is the value
measured at a distance of
200 mm from the objective
lens surface on the Optical
Pick-up Block with 7 mm
aperture.
2 Hz 20 kHz (0.5 dB)
780 790 nm
More than 90 dB
More than 90 dB

4-track 2-channel stereo

50 13,000 Hz (3 dB),
using Sony TYPE I tape
Continued on next page

MINI HI-FI COMPONENT SYSTEM

9-887-203-03

Sony Corporation

2007L02-1
2007.12

Audio Business Group

Published by Sony Techno Create Corporation

HCD-GNX660

Tuner section
FM stereo, FM/AM superheterodyne tuner
FM tuner section
Tuning range
87.5 108.0 MHz
Antenna
FM lead antenna
Antenna terminals
75 ohm unbalanced
Intermediate frequency
10.7 MHz
AM tuner section
Tuning range
530 1,710 kHz
(with the interval set at 10 kHz)
531 1,710 kHz
(with the interval set at 9 kHz)
Antenna
AM loop antenna
Antenna terminals
External antenna terminal
Intermediate frequency
450 kHz

General
Power requirements
Power consumption
Dimensions (w/h/d) (Approx.)
Mass (Approx.)
Supplied accessories:

127 V AC, 60 Hz
110 watts
280 326 385.5 mm
6.3 kg
Remote Commander (1)
Batteries (2)
AM loop antenna (1)
FM lead antenna (1)
Front speaker pads (8)
Sub woofer pads (4)
Video cord (1)

Notes on chip component replacement

Never reuse a disconnected chip component.
Notice that the minus side of a tantalum capacitor may be
damaged by heat.
Flexible Circuit Board Repairing
Keep the temperature of soldering iron around 270C
during repairing.
Do not touch the soldering iron on the same conductor of the
circuit board (within 3 times).
Be careful not to apply force on the conductor when soldering
or unsoldering.
CAUTION
Use of controls or adjustments or performance of procedures
other than those specified herein may result in hazardous
radiation exposure.

This appliance is classified as

a CLASS 1 LASER product.
This label is located on the rear
exterior.

Design and specifications are subject to change

without notice.

Unleaded solder
Boards requiring use of unleaded solder are printed with the lead
free mark (LF) indicating the solder contains no lead.
(Caution: Some printed circuit boards may not come printed with
the lead free mark due to their particular size.)

: LEAD FREE MARK

Unleaded solder has the following characteristics.
Unleaded solder melts at a temperature about 40C higher than
ordinary solder.
Ordinary soldering irons can be used but the iron tip has to be
applied to the solder joint for a slightly longer time.
Soldering irons using a temperature regulator should be set to
about 350C.
Caution: The printed pattern (copper foil) may peel away if
the heated tip is applied for too long, so be careful!
Strong viscosity
Unleaded solder is more viscous (sticky, less prone to flow)
than ordinary solder so use caution not to let solder bridges
occur such as on IC pins, etc.
Usable with ordinary solder
It is best to use only unleaded solder but unleaded solder may
also be added to ordinary solder.
SAFETY-RELATED COMPONENT WARNING!!
COMPONENTS IDENTIFIED BY MARK 0 OR DOTTED LINE WITH
MARK 0 ON THE SCHEMATIC DIAGRAMS AND IN THE PARTS
LIST ARE CRITICAL TO SAFE OPERATION. REPLACE THESE
COMPONENTS WITH SONY PARTS WHOSE PART NUMBERS
APPEAR AS SHOWN IN THIS MANUAL OR IN SUPPLEMENTS
PUBLISHED BY SONY.

HCD-GNX660

TABLE OF CONTENTS
1.
2.

SERVICING NOTES ................................................ 4

GENERAL
Locating the Controls ...................................................... 5
Setting the Clock ............................................................. 6

3.

DISASSEMBLY

3-1.
3-2.
3-3.
3-4.
3-5.
3-6.
3-7.
3-8.
3-9.
3-10.
3-11.
3-12.
3-13.
3-14.
3-15.
3-16.
3-17.

Disassembly Flow ...........................................................

Side Case, Top Case ........................................................
Loading Panel ..................................................................
Front Panel Assy ..............................................................
Tuner Pack .......................................................................
Tape Mechanism Deck, MIC Board ................................
PANEL Board, IR Board, VOL Board ............................
CD Mechanism Deck ......................................................
Back Panel, DC FAN (M891) .........................................
MAIN Board, ADC Board ...............................................
POWER Board, SPEAKER Board ..................................
SMASTER Board ............................................................
CDG Board, DRIVER Board, SW Board .......................
BD84 Board, Optical Pick-up .........................................
SENSOR Board ...............................................................
MOTOR (TB) Board .......................................................
MOTOR (LD) Board .......................................................

4.

TEST MODE .............................................................. 16

5.

MECHANICAL ADJUSTMENTS ....................... 20

6.

ELECTRICAL ADJUSTMENTS

7
8
8
9
9
10
10
11
11
12
12
13
13
14
14
15
15

Deck section .................................................................... 20

CD Section ...................................................................... 21

7.
7-1.
7-2.
7-3.
7-4.
7-5.
7-6.
7-7.
7-8.
7-9.
7-10.
7-11.
7-12.
7-13.
7-14.
7-15.
7-16.
7-17.
7-18.
7-19.
7-20.
7-21.
7-22.
7-23.
7-24.
7-25.
7-26.
7-27.
7-28.

DIAGRAMS .................................................................
Block Diagram CDG Section ...................................
Block Diagram Tape/Tuner Section .........................
Block Diagram Main Section ...................................
Block Diagram AMP Section ...................................
Block Diagram Display/Power Section ....................
Printed Wiring Board BD84 Board ..........................
Schematic Diagram BD84 Board .............................
Printed Wiring Boards CD Mechanism Sectiom ......
Schematic Diagram CD Mechanism Section ...........
Printed Wiring Board MAIN Board .........................
Schematic Diagram MAIN Board (1/3) ...................
Schematic Diagram MAIN Board (2/3) ...................
Schematic Diagram MAIN Board (3/3) ...................
Printed Wiring Boards PANEL Section ....................
Schematic Diagram PANEL Section .........................
Printed Wiring Boards
MIC,VOL and SPEAKER Boards ............................
Schematic Diagram
MIC,VOL and SPEAKER Boards ............................
Printed Wiring Board ADC Board ............................
Schematic Diagram ADC Board ..............................
Printed Wiring Board SMASTER Board (Side A) ...
Printed Wiring Board SMASTER Board (Side B) ....
Schematic Diagram SMASTER Board (1/2) ............
Schematic Diagram SMASTER Board (2/2) ............
Printed Wiring Board CDG Board ...........................
Schematic Diagram CDG Board ..............................
Printed Wiring Boards Power Board ........................
Schematic Diagram Power Board ............................
IC Pin Function Description ............................................

24
26
27
28
29
30
31
32
33
34
35
36
37
38
39
40
41
42
43
44
45
46
47
48
49
50
51
52
56

8.

EXPLODED VIEWS

8-1.
8-2.
8-3.
8-4.
8-5.

Case (Top), Back Panel Section ......................................

Front Panel Section .........................................................
Chassis Section ................................................................
CD Mechanism Deck Section-1 ......................................
CD Mechanism Deck Section-2 .....................................

9.

ELECTRICAL PARTS LIST ................................ 68

63
64
65
66
67

HCD-GNX660
Ver. 1.2

SECTION 1
SERVICING NOTES

NOTES ON HANDLING THE OPTICAL PICK-UP BLOCK

OR BASE UNIT
The laser diode in the optical pick-up block may suffer electrostatic
break-down because of the potential difference generated by the
charged electrostatic load, etc. on clothing and the human body.
During repair, pay attention to electrostatic break-down and also
use the procedure in the printed matter which is included in the
repair parts.
The flexible board is easily damaged and should be handled with
care.
NOTES ON LASER DIODE EMISSION CHECK
The laser beam on this model is concentrated so as to be focused on
the disc reflective surface by the objective lens in the optical pickup block. Therefore, when checking the laser diode emission,
observe from more than 30 cm away from the objective lens.

LASER DIODE AND FOCUS SEARCH OPERATION CHECK

Carry out the S curve check in CD section adjustment and check
that the S curve waveform is output several times.

CHANGE OF THE COMBINED BOARD SUFFIX

Suffix of the Main, Panel and Power combined board was changed
from -12 to -13.
Suffix of the SMASTER combined board was changed from -12 to
-13 or -21 (-13 and -21 are the same patterns).

HCD-GNX660
SECTION 2
GENERAL

This section is extracted

from instruction manual.

LOCATING THE CONTROLS

SYMBOLS

ALPHABETICAL ORDER
MR
AD

ALBUM + qk
ALBUM ql
CD es
CD SYNC 8
Deck A wh
Deck B qh
DIRECTION wg
DISC 1 ~ 3 qa
DISC SKIP/EX-CHANGE qs
Disc tray 6
DISPLAY 3
Display 5
EL

MASTER VOLUME ws
MIC 1/2 (jack) wf
MIC 1/2 LEVEL wd
MP3 BOOSTER 7
PHONES (jack) qj
POWER ILLUMINATOR wk
PRESET EQ wj
REC PAUSE/START 9
SZ

SUB WOOFER ON/OFF ed

TAPE A/B e;
Tape lid qh, wh
TUNER/BAND ea
TV wl

?/1 (power) ef
Z OPEN/CLOSE q;
N (play) qd
. OPERATION DIAL >
(forward/go backward) 1
M (fast forward) qk
m (rewind) ql
X (pause) qf
x (stop) qg
PUSH Z (Eject A) wh
PUSH Z (Eject B) qh

ECHO LEVEL wa
EQ BAND/MEMORY 4
GROOVE w;
ILLUMINATION/
SUB WOOFER LEVEL 2
KARAOKE wg

Top Panel

Front Panel

23456789

ef
ed
es
ea
e;
wl
wk
wj
wh

q;
qa
qs
qd
qf
qg
qh

qj
wg wf wdwswaw;qlqk
5

HCD-GNX660
This section is extracted
from instruction manual.

Remote control
TAPE wd
TUNER/BAND 7
TUNER MEMORY wg
TUNING MODE 5
VOLUME +/ qg

ALPHABETICAL ORDER
AE

ALBUM + qf
ALBUM qh
CD wf
CLEAR qk
CLOCK/TIMER SELECT 2
CLOCK/TIMER SET 4
DISC SKIP qd
DISPLAY wh
ENTER qs
EQ qj

The + button has a tactile dot.*

SYMBOLS

?/1 (power) 3
x (stop) qa
29, 31)
X (pause) ql
N (play) w;
. (go backward) ws
>+ (go forward) wa
m (rewind) q;
M (fast forward) 9

FZ

FM MODE 6
FUNCTION 8
PLAY MODE 5
REPEAT 6
SLEEP 1

wh
wg
wf
wd
ws
wa
w;

qs
qd

qh

qf

Press ?/1 to turn on the system.

Press CLOCK/TIMER SET.

CLOCK appears in the display. Then, the

hour indication flashes in the display.

Press . or >+ repeatedly to set

the hour.
Press ENTER.

The minute indication flashes in the

display.

5
6

9
q;
qa

qj

Use buttons on the remote for the operation.

ql

* Use the tactile dot as a reference

when operating the system.

1
2

4
5
6
7

qk

Setting the clock

Press . or >+ repeatedly to set

the minute.
Press ENTER.

The clock starts functioning.

To adjust the clock

1 Press CLOCK/TIMER SET.

SET appears in the display, then PLAY
SET flashes in the display.

2 Press . or >+ repeatedly to select

CLOCK SET, then press ENTER.
The hour indication flashes in the display.

3 Do the same procedures as step 3 to 6

above.
Notes

The clock settings are canceled when you disconnect

the power cord or if a power failure occurs.
You cannot set the clock in Power Saving Mode
(page 23).

qg

HCD-GNX660
SECTION 3
DISASSEMBLY
This set can be disassembled in the order shown below.

3-1. DISASSEMBLY FLOW

SET

3-2. SIDE CASE, TOP CASE

(Page 8)

3-3. LOADING PANEL

(Page 8)

3-4. FRONT PANEL ASSY

(Page 9)

3-5. TUNER PACK

(Page 9)

3-6. TAPE MECHANISM DECK,

MIC BOARD
(Page 10)

3-7. PANEL BOARD,

IR BOARD,
VOL BOARD
(Page 10)

3-8. CD MECHANISM DECK

(Page 11)

3-13. CDG BOARD

DRIVER BOARD,
SW BOARD
(Page 13)

3-9. BACK PANEL,

DC FAN (M981)
(Page 11)

3-10. MAIN BOARD,

ADC BOARD
(Page 12)

3-11. POWER BOARD,

SPEAKER BOARD
(Page 12)

3-12. SMASTER BOARD,

(Page 13)

3-14. BD84 BOARD,

OPTICAL PIC-UP
(Page 14)

3-15. SENSOR BOARD

(Page 14)

3-16. MOTOR (TB) BOARD

(Page 15)

3-17. MOTOR (LD) BOARD

(Page 15)

HCD-GNX660
Note: Follow the disassembly procedure in the numerical order given.

3-2. SIDE CASE, TOP CASE

qf case (top)
7 screw
(case 3 TP2)
(312)

qs two screws
(+BVTP 38)
8 screw
(+BVTP 38)
qa two tapping screws

9
qd

0 case (side-L)

6 screw
(case 3 TP2)
(38)

3 screw
(+BVTP 38)

2 screw
(case 3 TP2)
(312)

5 case (side-R)
1 screw (case 3 TP2)
(38)

3-3. LOADING PANEL

4 loading panel

CD mechanism deck (CDM74KFS-F1BD84)

1 Turn the pulley to the arrow direction.

Pulley
3

Front side

2 Pull out disc tray.

HCD-GNX660
3-4. FRONT PANEL ASSY
q; connector
(CN503)

8 connector
(CN131)

7 connector
(CN121)
6 wire (flat type)
(CN509)
5 wire (flat type)
(CN201)

9 connector
(CN205)
3 tapping screw

2 tapping screw

4 front panel assy

1 four screws
(+BVTP 38)

3-5. TUNER PACK

3 tuner pack

2 wire (flat type)

(CN1)

1 two screws
(+BVTT 36)

HCD-GNX660

3-6. TAPE MECHANISM DECK, MIC BOARD

2 tape mechanism deck

1 six screws
(+BVTP2.6)

lug

front panel

6 holder (TC-L)
8 four screws
(+BVTP2.6)
5 holder (TC-R)

7 three
mic knobs

9 bracket
(pivot)

qs bracket
(TC)
qd MIC board

4 splring (L)
qa three screws
(+BVTP38)
3 spring (R)

3-7. PANEL BOARD, IR BOARD, VOL BOARD

5 PANEL board

1 eighteen screws
(+BVTP2.6)

6 IR board
7 four screws
(+BVTP2.6)
2

4 connector
(CN1452)

9 knob jog assy

0 VOL board

8 accessory nut

7 knob (vol)

10

front panel

3 wire (flat type)

(CN1402)

HCD-GNX660

3-8. CD MECHANISM DECK

1 CD mechanism deck

2 wire (flat type)

(CN351)
3 wire (flat type)
(CN701)

4 wire (flat type)

(CN1001)
(CDG board)
5 connector
(CN1003)
(CDG board)

MAIN board

3-9. BACK PANEL, DC FAN (M891)

4 screw
(+BVTP 38)

5 two screws
(+BVTP 38)

6 back panel

1 screw
(+BVTP 38)
7 two screws
(+BVTP 38)

9 connector
(CN580)
8 DC fan
(M891)

2 three screws
(+BVTP 38)
3 three screws
(+BVTP 38)

11

HCD-GNX660

3-10. MAIN BOARD, ADC BOARD

2 connector
(CN501)

3 two screws
(+BVTT 36)
1 wire (flat type)
(CN105)
7 connector
(CN590)

6 MAIN board
9 ADC board

8 board to board connector

(CN381,CN01)
4 two screws
(+BVTP 38)

5 shield plate (TC MAIN)

3-11. POWER BOARD, SPEAKER BOARD

8 bracket (support top)

7 three screws
(+BVTP 38)

qs bracket (support pwb)

ql bracket (SMPS -B5)

qj bracket (SMPS 5ch)

qd two tapping screws

qk three screws (+BVTP 38)

q; bracket
(support front)

qa tapping screw
4 connector
(CNP1100)

9 two screws
(+BVTP 38)

qf bracket (trans 5ch)

qg screw
(+BVTP 38)

2 three screws
(+BVTT 36)

wa two screws
(+BVTP 38)

1 screw
(+BVTT 36)

w; POWER board
qh three screws
(+BVTP 38)

3
ws SPEAKER board

5 connector
(CN1101)

12

6 connector
(CN1200)

HCD-GNX660
3-12. SMASTER BOARD

1 two screws
(+BVTT 36)
2 heat sink (SMAS)
4 three screws
(+BVTT 36)

3 two screws
(+BVTT 36)

5 SMASTER board

3-13. CDG BOARD, DRIVER BOARD, SW BOARD

1 two screws
(+BVTP 310)

2 CDG board

3 three screws
(+BVTP 310)

4 cover (CDM)

5 two screws
(+BTTP (M2.6))
8 DRIVER board
7 connector (CN703)

9 screw
(+BTTP (M2.6))
0 SW board

6 wire (flat type) (CN702)

13

HCD-GNX660

3-14. BD84 BOARD, OPTICAL PICK-UP

1 floating screw
(+PTPWH M2.6)

2 holder (213) ASSY

5 two insulators

qf optical pick-up
(KSM-215DCP/C2NP)

4 two coil springs

(insulator)

8 two insulators

3 two floating screws

(+PTPWH M2.6)

7 two coil springs

(insulator)
6 two floating screws
(+PTPWH M2.6)

qs wire (flat type)

(CN101)
qd BD84 board

qa Remove the four solderings of motor.

q; screw (+BVTP 2.6 (3CR))

3-15. SENSOR BOARD

1 floating screw
(+PTPWH M2.6)
2 tray

8 screw
(+BTTP (M2.6))
3 belt (table)
0 SENSOR board
4 floating screw
(+PTPWH M2.6)
5 pulley (table)

6 floating screw
(+PTPWH M2.6)
7 gear (geneva)

14

9 connector
(CN731)

HCD-GNX660

3-16. MOTOR (TB) BOARD

2 stopper

1 stopper
7 table motor assy (M741)

3 wire (flat type) 5 core (CN742)

8 MOTOR (TB) board
6 Remove the two solderings of motor.
5 two screws
(+BTTP (M2.6))

3-17. MOTOR (LD) BOARD

2 two screws
(+BTTP (M2.6))
4 Remove the two solderings of motor.
3 MOTOR (LD) board

5 loading motor assy (M751)

1 belt (loading)

15

HCD-GNX660
SECTION 4
TEST MODE
[PANEL TEST MODE]
This mode is used to check the fluorescent indicator tube,
LEDs, buttons, MASTER VOLUME knob, model,
destination, software version and VACS level.
Procedure:
1. Press x button, [ILLUMINATION] button and [DISC 2]
button simultaneously.
2. All LEDs and segments in fluorescent indicator tube are lighted
up. All LEDs are lighted up in red color except the SUB
WOOFER ON/OFF LED (green).
3. When you want to enter to the software version display mode,
press [DISC 1] button. The model infomation is displayed.
Press [DISC 1] button again to view destination infomation.
4. Each time [DISC 1] button is pressed, the display changes from
MC version, SYS version, UI version, CD version, CDDM
version, CDMA version, CDMB version, BDA version, BDB
version, ST version, TA version, TM version, TC version in
this order, and returns to the model version display.
5. When [DISC 3] button is pressed while the version numbers
are being displayed except model and destination, the date of
the software creation appear. When [DISC 3] button is pressed
again, the display returns to the software version display. When
[DISC 1] button is pressed while the date of the software
creation is being displayed, the date of the software creation
is displayed in the same order of software version display.
6. Press [DISC 2] button, the key check mode is activated.
7. In the key check mode, the fluorescent indicator tube displays
K 0 V0. Turn the [OPERATION DIAL] clockwise, K value
increases by one. Turn the [OPERATION DIAL] counterclockwise, K value increases by one. Each time a button is
pressed, K value increases. Press other buttons on main unit
to check whether the button is detected. However, once a button
has been pressed, it is no longer taken into account.
V value increases in the manner of 0,1, 2, 3 ... if [MASTER
VOLUME] knob is turned clockwise, or it decreases in the
manner of 0, 9, 8, 7 ... if [MASTER VOLUME] knob is turned
counter-clockwise.
8. When [DISC 3] button is pressed after all LEDs and segments
in fluorescent indicator tube light up, the fluorescent indicator
tube displays VACS A. A is VACS level which is trigger by
signal level.
9. When [DISC SKIP/EX-CHANGE] button is pressed after all
LEDs and segments in fluorescent indicator tube light up,
alternate segments in fluorescent indicator tube would light
up. If you press [DISC SKIP/EX-CHANGE] button again, another
half of alternate segments in fluorescent indicator tube would
light up. When [DISC SKIP/EX-CHANGE] button is pressed
again, all segments lights off. Press [DISC SKIP/EX-CHANGE]
button again would cause all segments lights up.
10. To release from this mode, press three buttons in the same
manner as step 1, or disconnect the power plug.

[COMMON TEST MODE]

This mode is used to check operations of the respective sections
of Amplifier and Tape.
Procedure:
* To enter Common Test Mode
1. Press x button, [ILLUMINATION] button and [DISC 3]
button simultaneously.
2. The CD ring indicators and line below CD ring indicator flash
synchronously on the fluorescent indicator tube. The function
is changed to TV.
* Check of Amplifier
1. Press [EQ BAND/MEMORY] button repeatedly until a message
GEQ MAX appears on the fluorescent indicator tube. GEQ
increases to its maximum.
2. Press [EQ BAND/MEMORY] button repeatedly until a message
GEQ MIN appears on the fluorescent indicator tube. GEQ
decreases to its minimum.
3. Press [EQ BAND/MEMORY] button repeatedly until a message
GEQ FLAT appears on the fluorescent indicator tube. GEQ
is set to flat.
4. When the [MASTER VOLUME] knob is turned clockwise even
slightly, the sound volume increases to its maximum and a
message VOLUME MAX appears on the fluorescent
indicator tube.
5. When the [MASTER VOLUME] knob is turned counterclockwise even slightly, the sound volume decreases to its
minimum and a message VOLUME MIN appears on the
fluorescent indicator tube.
* Tape function
1. When a tape is inserted in Deck B and recording is started, the
function is changed to TV automatically. When [CD SYNC]
button is pressed during recording in function, ALC
(Automatic Logic Control) is turned on.
2. During recording, press m button will stop the recording
and the function is changed to TAPE B and rewind the tape in
Deck B until the recording start position and playback of the
tape in Deck B is started. If the [REC PAUSE/ START] button
is pressed for a pause and pressed again to resume recording
during recording time, when the tape is rewind, the tape will
be rewind until the position where the pause is applied.
* To release from Common Test mode.
1. To release this mode, press ?/1 button.
2. The cold reset is enforced at the same time.

[COLD RESET]
The cold reset clears all data including preset data stored in
the RAM to initial conditions. Execute this mode when
returning the set to the customer.
Procedure:
1. Press ?/1 button to turn on the set.
2. Press x button, [ILLUMINATION/SUB WOOFER LEVEL]
button, and ?/1 button simultaneously.
3. The message COLD RESET appears on the fluorescent
indicator tube. then, the fluorescent indicator tube becomes
blank for a while, and the set is reset.

16

HCD-GNX660

[VACS ON/OFF]
This mode is used to switch ON and OFF the VACS (Variable
Attenuation Control System).
Procedure:
1. Press ?/1 button to turn on the set.
2. Press x button and [DIRECTION] button and [DISC 1] button
simultaneously. The message VACS OFF or VACS ON
appears on the fluorescent indicator tube.
[TUNER STEP CHANGE]
The step interval of AM channels can be toggled between 9
kHz and 10 kHz.
Procedure:
1. Press ?/1 button to turn on the set.
2. Press [TUNER/BAND] button repeatedly to select the AM.
3. Press ?/1 button to turn off the set.
4. Press [ILLUMINATION/SUB WOOFER LEVEL] button and
?/1 button simultaneously. The system will turn on
automatically. The message AM 9K STEP or AM 10K
STEP appears on the fluorescent indicator tube and thus the
channel step is changed.
[CD SERVICE MODE]
This mode let you move the CD sled motor freely. Use this
mode when you want to clean the optical pick-up.
Procedure:
1. Press ?/1 button to turn on the set.
2. Select CD function.
3. Press x button, [ILLUMINATION/SUB WOOFER LEVEL]
button and Z OPEN/CLOSE button simultaneously.
4. The CD service mode is activated. The message SERVICE
MODE appears on the fluorescent indicator tube.
5. With the CD in stop status, press M button to move the
optical pick-up to outside track, or press m button to move
to inside track. The message SLED OUT or SLED IN
appears on the fluorescent indicator tube.
6. To turn on or off the laser, press [GROOVE] button. The
message LD ON or LD OFF appears on the fluorescent
indicator tube.
7. To release from this mode, press ?/1 button.

[CD AGING MODE]

This mode can be used for operation check of CD section.
If an error occurs, the aging operation would stops and the
status is displayed.
If there were no error occurs, the aging operation would
continue repeatedly.
Procedure:
1. Press ?/1 button to turn on the set.
2. Select CD function.
3. Load three discs on the disc tray.
4. Press [PLAY MODE] button on the remote repeatedly to select
the ALL DISCS mode, and press the [REPEAT] button on
the remote repeatedly to select REPEAT OFF mode.
5. Press x button, [ILLUMINATION/SUB WOOFER LEVEL]
button, and[DISC SKIP/EX-CHANGE] button
simultaneously.The CD ring indicator and line below CD
ring indicator turn on afternately to indicate aging mode.
6. Aging operation is started.
7. To release from this mode, press ?/1 button or disconnect
the power plug.
Aging mode sequence:
Start (from disc 1)

Disc chucking

TOC reading

Play first track for 2 seconds

Play last track for 2 seconds

EX-CHANGE open/close

Open the disc tray

Disc skip

Close the disk tray

Change to the next disc

17

HCD-GNX660

Display when an error occurred (CD Error Code Mode)

Procedure:
1. Press x button, [ILLUMINATION/SUB WOOFER
LEVEL] button and [DISC 1] button simultaneously to
enter the error code display mode.
2. The fluorescent indicator tube displays the number of total
error.
3. Each time m or M button is pressed, display change as
below.
Display of total error
M
>

Display of Mechanical errors

direction
M
>

direction
m

Display of no disc errors

direction

direction

4. To clear the error record, operate the cold reset. (Refer to the
COLD RESET)
5. To release from this mode, press the ?/1 button or
disconnect the power plug.
1) Display of total error
Display

EM**ED**
EM**: The number of mechanical errors.
ED**: The number of no disc errors after chucking the disc.
2) Display of mechanical errors
Display

M*$$%%&&##00
M*: The number of mechanical error (00 is latest one)
(Rotate . > knob in the direction of either to display next
error)
$$: Not used
%%: Loading related error (Second figure is not used)
D: Stop by the problem other than mechanical problem while
closing.
E: Stop by the problem other than mechanical problem while
opening.
C: Stop by the problem other than mechanical problem while
chucking up.
F: Stop by the problem other than mechanical problem while
chucking down.
&&: Emerging error
01: Stop while chucking up.
02: Stop while chucking up.
03: Time-out of EX-CHANGE open.
05: Time-out of EX-CHANGE close.
##: Not used

18

3) Display of no disc errors

Display

D*$$%%&&##00
D*: The number of no disc error (00 is latest one)
(Rotate . > knob in the direction of either to display next
error)
$$: Error type
01: Focus error
02: GFS error
03: Setup error
%%: Not used
&&:
00: No disc judgment without chucking retry.
01: No disc judgment after chucking retry.
##: The state when judged as no disc
01: Stop
02: Setup
03: TOC reading
04: Access
05: Playback
06: Pause
07: Manual search (Play)
08: Manual search (Pause)

[CD REPEAT 5 LIMIT OFF MODE]

The number of repeat for CD playback is 5 times when the
repeat mode is REPEAT ALL. This mode enables CD to
repeat playback for limitless times.
Procedure:
1. Press ?/1 button to turn on the set.
2. Select CD function.
3. Press x button, [CD] button and [DISC 1] button
simultaneously to enter the CD repeat 5 limit off mode and
the fluorescent indicator tube displays LIMIT OFF.
4. To release from this mode, operate the cold reset. (Refer to
the COLD RESET)
[CD SHIP MODE (WITH MEMORY CLEAR)]
This mode moves the optical pick-up to the position durable
to vibration and clears all data including preset data stored in
the RAM to initial conditions. Use this mode when returning
the set to the customer after repair.
Procedure:
1. Press ?/1 button to turn on the set.
2. Select CD function.
3. Press x button, [DIRECTION] button and ?/1 button
simultaneously. The set will turn off automatically.
4. After the STANDBY blinking display finishes, a message
MECHA LOCK is displayed on the fluorescent indicator
tube and the CD ship mode is set.

HCD-GNX660

[CD SHIP MODE (WITHOUT MEMORY CLEAR)]

This mode moves the optical pick-up to the position durable
to vibration. Use this mode when returning the set to the
customer after repair.
Procedure:
1. Press ?/1 button to turn on the set.
2. Select CD function.
3. Press [CD] button and ?/1 button simultaneously. The set
will turn off automatically.
4. After the STANDBY blinking display finishes, a message
MECHA LOCK is displayed on the fluorescent indicator
tube and the CD ship mode is set.
[CD POWER MANAGE]
This mode let you switch on or off power supply to the BU
during TUNER function.
When CD POWER is set to OFF, the power supply to the BU
is cut off during TUNER function. It will increase the time
taken to access CD when function change from TUNER to
CD but it will improve tuner reception.
When CD POWER is set to ON, the power supply to the BU
is not cut off during TUNER function. It will reduce the time
taken to access CD when function change from TUNER to
CD but it will decrease tuner reception performance.
Procedure:
1. Press ?/1 button to turn on the set.
2. Select CD function.
3. Press ?/1 button to turn off the set.

[CD TRAY LOCK MODE]

This mode let you lock the disc tray. When this mode is
activated, the disc tray will not open when Z OPEN/CLOSE
button or [DISC SKIP/EX-CHANGE] button is pressed. The
message LOCKED will be displayed on the fluorescent
indicator tube.
Procedure:
1. Press ?/1 button to turn on the set.
2. Select CD function.
3. Press x button and Z OPEN/CLOSE button
simultaneously and hold down until LOCKED or
UNLOCKED displayed on the fluorescent indicator tube
(around 5 seconds).
[TCM OFFLINE MODE]
This mode prevents set from power off automatically when
TCM is not connected.
Therefore, measurements can be done even when TCM is not
connected during production.
Procedure:
1. When the set in turned off, press [EQ BAND/MEMORY]
button, [TAPE A/B] button and ?/1 button simultaneously.
The set will turn on automatically.
2. The message TCM OFFLINE will be displayed on the
fluorescent indicator tube.

4. Press x button and ?/1 button simultaneously. The set

will turn on automatically.
5. The message CD POWER ON or CD POWER OFF will
be displayed on the fluorescent indicator tube.

19

HCD-GNX660
SECTION 5
MECHANICAL ADJUSTMENTS
Precaution
1. Clean the following parts with a denatured alcohol-moistened
swab:
record/playback heads pinch rollers
erase head
rubber belts
capstan
idlers
2. Demagnetize the record/playback head with a head
demagnetizer.
3. Do not use a magnetized screwdriver for the adjustments.
4. After the adjustments, apply suitable locking compound to
the parts adjusted.
5. The adjustments should be performed with the rated power
supply voltage unless otherwise noted.
Torque Measurement
Mode

FWD

Torque meter

CQ-102C

FWD
back tension

CQ-102C

FF/REW

CQ-201B

Meter reading
2.9 mN m to 6.9 mN m
30 to 70 g cm
(0.42 0.97 oz inch)
0.15 mN m to 0.59 mN m
1.6 to 6 g cm
(0.022 0.08 oz inch)
4.8 mN m to 16.7 mN m
49 to 170 g cm
(0.69 2.36 oz inch)

SECTION 6
ELECTRICAL ADJUSTMENTS
DECK SECTION

0 dB=0.775 V

1. Demagnetize the record/playback head with a head

demagnetizer.
2. Do not use a magnetized screwdriver for the adjustments.
3. After the adjustments, apply suitable locking compound to the
parts adjust.
4. The adjustments should be performed with the rated power
supply voltage unless otherwise noted.
5. The adjustments should be performed in the order given in
this service manual. (As a general rule, playback circuit
adjustment should be completed before performing recording
circuit adjustment.)
6. The adjustments should be performed for both L-CH and RCH.
7. Switches and controls should be set as follows unless otherwise
specified.
Test Tape
Tape
P-4-A100

Signal
10 kHz, 10 dB

Used for
Azimuth Adjustment

RECORD/PLAYBACK HEAD AZIMUTH ADJUSTMENT

DECK A

DECK B

Note: Perform this adjustments for both decks

Procedure:
1. Mode: Playback

test tape
P-4-A100
(10 kHz, 10 dB)

MAIN board
CN121
Pin 3 (L-CH)
Pin 1 (R-CH) level meter
set

MAIN board
CN121
Pin 2 (GND)

20

HCD-GNX660

2. Turn the adjustment screw and check output peaks. If the peaks
do not match for L-CH and R-CH, turn the adjustment screw
so that outputs match within 1dB of peak.

within
1dB

L-CH
peak

within
1dB

Output
level

Screw
position

CDG SECTION
Note:

1. CDG Block is basically designed to operate without

adjustment. Therefore, check each item in order given.
2. Use YEDS-18 disc (3-702-101-01) unless otherwise indicated.
3. Use an oscilloscope with more than 10M impedance.
4. Clean the object lens by an applicator with neutral detergent
when the signal level is low than specified value with the
following checks.
S-curve Check
Connection:

R-CH
peak
L-CH
peak

Screw
position

R-CH
peak

oscilloscope
BD84 board

3. Mode: Playback

JPO102 (FE1)
TP117 (VC)

test tape
P-4-A100
(10 kHz, 10 dB)
L-CH

oscilloscope
pin 3
pin 2

MAIN
board
CN121
set

R-CH
pin 1
waveform of oscilloscope

in phase 45
good

90 135 180

Procedure:
1. Connect an oscilloscope to test point JPO102 (FE1) and TP
117(VC) on the BD84 board.
2. Turn the power on.
3. Put the disc (YEDS-18) in and turned power switch on again
and actuate the focus search. (actuate the focus search when
disc table is moving in and out)
4. Check the oscilloscope waveform (S-curve) is symmetrical
between A and B. And confirm peak to peak level within
2.4 1 Vp-p.
S-curve waveform
symmetry

wrong

4. After the adjustments, apply suitable locking compound to

the pats adjusted.
Adjustment Location: Playback Head (Deck A).
Record/Playback Head (Deck B).

within 2.4 1 Vp-p

Note:
Try to measure several times to make sure than the ratio
of A : B or B : A is more than 10 : 7.
Take sweep time as long as possible and light up the
brightness to obtain best waveform.
Checking Location: BD84 board (SIDE B)
(See page 23.)

azimuth
screw

21

HCD-GNX660

E-F Balance Check

Connection:

RFAC Level Check

Connection:
oscilloscope

oscilloscope

BD84 board
TP124 (RFAC)
TP117 (VC)

BD84 board
+

JPO103 (TE1)
TP117 (VC)

Procedure:
1. Connect an oscilloscope to test point TP124 (RFAC) and TP
117(VC) on the BD84 board.
2. Turn the power on.
3. Put the disc (YEDS-18) in to playback the number five track.
4. Confirm that oscilloscope waveform is clear and check RFAC
signal level is correct or not.
Note:

A clear RFAC signal waveform means that the shape can be

clearly distinguished at the center of the waveform.

RFAC signal waveform

VOLT/DIV: 200 mV
TIME/DIV: 500 ns

level: 0.9 0.4 Vp-p

Procedure:
1. Connect an oscilloscpe to test point TPO103 (TE1) and TP117
(VC) on the BD84 board.
2. Turn the power on.
3. Select the function CD.
4. Press three buttons of [ENTER], M , and
[SURRUUND MODE] simultaneously to set the CD service
mode.
5. Put the disc (YEDS-18) in to playback the number five track.
6. Press the . button. The message TRAVERSE is
displayed. (The tracking servo and the sledding servo are
turned OFF)
7. Check the level B of the oscilliscope's waveform and the A
(DC voltage) of the center of the Traverse waveform.
Confirm the following :
A/B x 100 = less than 22%
Center of
the waveform

Traverse Waveform

Checking Location: BD84 board (SIDE B)

(See page 23.)

A (DC
voltage)

0V

level: 1.0 0.5 Vp-p

8. Press the . button. The message TRAVERSE is

displayed. (The tracking servo and sledding servo are turned
ON)
Confirm the C (DC voltage) is almost equal to the A (DC
voltage) is step 5.
9. To exit from this mode, perform as follows.
1) Move the optical pick-up to the most inside track.
2) Press three buttons of x , [CLEAR], and [DISPLAY]
simultaneously. (cold reset)
Notes:

Always move the optical pick-up to most inside track

when exiting from this mode. Otherwise, a disc will not
be unloaded.
Do not run the sled motor excessively, otherwise the gear
can be chipped.

Traverse Waveform

C (DC
voltage)

0V
Tracking servo
Sled servo
OFF

Tracking servo
Sled servo
ON

Checking Location: BD84 board (SIDE B) (See page 23.)

22

HCD-GNX660

Checking Location:
BD84 BOARD (SIDE B)

TP117 (VC)
JPO103 (TE1)

IC101
JPO102 (FE1)

TP124 (RFAC)

23

HCD-GNX660
SECTION 7
DIAGRAMS
For schematic diagrams.
Note:
All capacitors are in F unless otherwise noted. (p: pF)
50 V or less are not indicated except for electrolytics and
tantalums.
All resistors are in and 1/4 W or less unless otherwise
specified.

%
: indicates tolerance.

f
: internal component.
2 : nonflammable resistor.
5 : fusible resistor.
Note: The components identified by mark 0 or dotted line
with mark ! are critical for safety.
Replace only with part number specified.
C : panel designation.
A : B+ Line.
B : B Line.
Voltages and waveforms are dc with respect to ground
under no-signal conditions.
BD84 board
no mark: CD PLAY
Other boards
no mark: TUNER (FM/AM)
(
) : CD PLAY
<
> : TAPE PLAY
[
] : TAPE REC
*
: Impossible to measure
Voltages are taken with a VOM (Input impedance 10 M).
Voltage variations may be noted due to normal production tolerances.
Waveforms are taken with a oscilloscope.
Voltage variations may be noted due to normal production tolerances.
Signal path.
F
: AUDIO
f
: TUNER (FM/AM)
E
: TAPE PLAY (DECK A)
d
: TAPE PLAY (DECK B)
G
: RECORD
J
: CD PLAY
N
: MIC INPUT
c
: CDG
g : VIDEO

Note on Printed Wiring Boards:

Note:
X : parts extracted from the component side.

: Pattern from the side which enables seeing.

(The other layers' patterns are not indicated.)
Caution:
Parts face side:
(Side A)
Pattern face side:
(Side B)

Indication of transistor.

24

Parts on the parts face side seen from

the parts face are indicated.
Parts on the pattern face side seen from
the pattern face are indicated.

These are omitted.

B E

Q
B C

E
These are omitted.

Q
B

E
These are omitted.

HCD-GNX660

WAVEFORMS

CIRCUIT BOARDS LOCATION

BD84 BOARD

MAIN BOARD

1 IC101 wa TEI

SMASTER BOARD

1 IC800 2

1 IC401 qa XC-OUT

SENSOR board

0.8 Vp-p

2.7 Vp-p

BD84 board
SW board

0.15 Vp-p

MOTOR (LD) board

20.3 nsec

TUNER pack

30.5 sec

1V/DIV, 10 sec/DIV

0.2V/DIV, 0.2 msec/DIV

2 IC101 wd FEI

0.5V/DIV, 20 nsec/DIV

POWER board

DRIVER board
CDG board

2 IC401 qd X-OUT

MOTOR (TB) board

ADC BOARD
PANEL board

3.3 Vp-p

0.4 Vp-p

SPEAKER board

1 IC03 1

IR board

2 sec
1V/DIV, 1 sec/DIV

0.1V/DIV, 1 msec/DIV

3 IC101 ra RFAC

3 T101 5

4 Vp-p
MAIN board

TAPE REC only

67 Vp-p

0.9 0.4 Vp-p

81.3 nsec

VOL board

SMASTER board

2V/DIV, 50 nsec/DIV

ADC board

10.5 sec
0.2V/DIV, 0.5 sec/DIV

CDG BOARD

50V/DIV, 10 sec/DIV

4 T101 4

MIC board

TAPE REC only

1 IC1001 tl XI1

82 Vp-p

10.5 sec
50V/DIV, 10 sec/DIV

5.9 Vp-p

69.84 sec
2V/DIV, 50 nsec/DIV

HCD-GNX660

25

25

HCD-GNX660
7-1. BLOCK DIAGRAM

CDG SECTION

AOUT2 86

OPTICAL PICK-UP
BLOCK
(KSM-215DCP/C2NP)

MAIN
SECTION
(Page 28)

CD-L

AOUT1 81

R-CH
CD MUTE
Q237,287

IC101
RF AMP, DSP, DAC

CD MUTE DRIVE
Q307, 308

DETECTOR
VCC

+3.3V

IC301

VC

IC303

MP3 DECODER

25 VC

REG
A

26 A

PCMD1 61

11 SDO0

VDD 55

27 B

LRCKI 62

16 LRCKIA

VDD 21

28 C

LRCK 63

19 SFSY/LRCK1B

29 D

PCMD 65

14 SDI0

19 E

BCK 66

20 F

BCK1 60

+3.3V

VDDM 40

15 BCKIA

IC701

18 SBSY/BCK1B

TABLE LOADING
MOTOR DRIVER

XLAT 104

FOCUS
COIL

TRACKING
COIL

SENS 107
11 TFDR

SCOR 115

SRMSTB 41

MP3 CS
MP3 RST

XLT

SCOR

CLOCK

SENS

SENS

CLOCK

SCOR

XLT

12 TRDR

13 FFDR

CH2RIN

14 FRDR

CH3FIN

23

9 SFDR

CH3RIN 22

10 SRDR

23 MP3 CS

E-1 45

22 MP3 RST

E-2 44

E-3 43

MP3 DATA IN

XTACN

XLAT

CD-DATA

XRST

28 XTACN

14 CH1OUT-F

34 CD MUTE

17 CH3OUT-F
M102
(SLED)

5
OPIN+

6 MDP

18 CH3OUT-R
MUTE 20

100 XRST

WFCK 110
SBSO 98

S101
(LIMIT)

7 SSTP

IC1001

IC1005
6

VIDEO D/A
8

13

12 11

10

EXCK 99

MUTE

3 DATA

SENTSC 55

2 CLCK

RESET 54

Q1004
PAL/_NTSC
Q1002,1006

DRAM

1,2,24,25

25,27,29,30

9-12,14-17

15-22

VA0-7

14 RAS
26 CAS

WE 3
CE 22

13 WE
28 CE

M+9V

E-3

IIC-DATA 30

ROTARY
E-2 ENCODER
E-1

IIC-CLK 29

35 33 31 32 12

S751
(OPEN)

+B SWITCH
Q1007,1008

IIC-CLK

+5V REG

IIC-DATA

1 VIN

CDG-POWER

VOUT 3

CN402

IC1006
VIDEO BUFFER

Q1010
VMUTE

IC1003

PWR
SAVE

4 VIN

VCC

VSAG 3

J1001

VOUT 2

VIDEO
OUT

VMUTE

2 TXD1

MUTE DATA

CDG-RST

CDG-DET

CNVSS

RESET

RTS1
CLK1

ON BOARD
PROGRAM

RXD1
CN VSS
RESET

R-CH is omitted due to same as L-CH.

SIGNAL PATH
XI1

RAS 4
CAS 23

CDG-RST

CDG-DET

VDOUT 44

OUT1 4
OUT2 2

S711

XO1

A0-7

VD0-3

VCC

EVER+3.3V

GDET 37

M741
(TABLE)

INVERTER
Q731

HALT_CLK

Q1001

DEN 52

NO401

PDOWN 56

5 SFSY

M751
(TABLE LOADING)

IC731

SYSTEM
CONTROL

MUTE DATA

TBL ADDRESS
SENS

Q1005,1009
4 SBSY

IC1002

DQ1-4

9 RIN
7 FIN

IC401 (1/5)

CDG-POWER

16 CH4OUT-F

MUTE DATA

HALT_CLK

15 CH4OUT-R
M101
(SPINDLE)

IC712
TABLE MOTOR DRIVER

OPEN SW 41

82 CD-CLK

13 CH1OUT-R
CH2FIN

TBL_SENS 42

21 SENS

XRST
5

TM-F 46

24 MP3 LP

19 SCOR

DATA

11 CH2OUT-R
CH1RIN

T+

CLOCK 105

OUT 26
VREF
CH1FIN 4

12 CH2OUT-F

DATA

TM-R 47

MP3 DATA OUT

RESET

IC251

RESET 2

7 MP3 CLK

CNVSS

DATA 102

SL/SP MOTOR
DRIVER
F+

XRST 100

MICS 4

XRST

OUT2 2

CNVSS

VR

37 PD

XTACN

OUT1 4

7 FIN

MP3 LP

MILP 5
XTACN 95

PD

MP3 DATA

9 RIN

LM-F 48

RESET

LM-R 49

VMUTE

MP3 CLK

26 MP3 REQ
25 MP3 ACK

CDG-DET

MICK
MIDIO

78 XTAI

MP3 ACK

VMUTE

77 XTAO
X171
16.9MHz

27 MP3 STB

MP3 REQ

CDG-DET

MIACK
GND

MP3 STB

PO11/BUCK/AD14 36

CDG-POWER

STANBY

36 LD

CDG RST

LD
DRIVER
Q10

CDG-RST

LD

: CD

60

59

: CDG
: VIDEO

X1002
14.31818MHz

HCD-GNX660

26

26

HCD-GNX660
Ver. 1.2
7-2. BLOCK DIAGRAM

TAPE/TUNER SECTION

DECK-A
75

L CH
PB
HEAD

AIN1
A

R CH

EQ OUT1

R-CH

76
SWITCH DRIVE
Q110, 111

Q166

DECK-B

79

78

TAI1

PB OUT1

TC-PB-L

80

R-CH

MUTE
Q103

1
R-CH

IC101(1/2)
Q154, 155

R CH

L
R

TEST
CONNECTOR

MUTE DRIVE
Q303, 304

DECK A/B SELECT,

PB/REC EQUALIZER AMP

Q109

MAIN
SECTION
(Page 28)

CN111

BIN1

L CH
REC/PB
HEAD

SWITCH DRIVE
Q107, 108

R-CH
C174, L104
BIAS
TRAP

R-CH

17

R-CH

REC-OUT1

REC IN1

EQ

REC-OUT-L

15

MAIN
SECTION
(Page 28)

MUTE
Q175

T101
ERASE
HEAD

BIAS+9V

BIAS OSC
Q101

TC REC
MUTE DRIVE
Q301, 302

Q113,114

TAPE
MECHANISM
DECK

IC401(2/5)
SYSTEM CONTROL
(CD/TAPE MECHANISM CONTROL)

REC(FWD)
B SHUT
A SHUT

90 B SHUT
89 A SHUT

BHALF
AHALF

91 B-HALF
63 A-HALF

ATRGM+

A TRIG
DRIVE
Q122, 123

17 A-TRIG

BTRGM+

B TRIG
DRIVE
Q118, 119

19 B-TRIG

CAP M+

CAP MOTOR
DRIVE
Q120, 121

TC-MUTE 5

IC403(1/2)
SIGNAL IN/OUT CONTROL
18 CAPM-CNT

CN101
21 TC-RELAY
FM/AM TUNER UNIT

FM 75
COAXIAL

ST-R

AM ANT
AM ANT
ANTENNA

69 IO-EXP-CLK

RESET 2

68 IO-EXP-RST

DI1 26

ST-L
R-CH

MAIN
SECTION
(Page 28)

66 IO-EXP-DATA-OUT

20 REC BIAS

40 TUNED

TUNED
AM

70 IO-EXP-LAT

CLK 3

7 REC-MUTE

ST-L
FM ANT

LATCH 4

39
37
38
36

ST-DIN
ST-DOUT
ST-CLK
ST-CE

HCD-GNX660

27

27

ST-DIN
ST-DOUT
ST-CLK
ST-CE

R-CH is omitted due to same as L-CH.

SIGNAL PATH
: TUNER (FM/AM)
: PLAYBACK (DECK A)
: PLAYBACK (DECK B)
: RECORD

HCD-GNX660
7-3. BLOCK DIAGRAM

MAIN SECTION
IC1400
DIGTAL ECHO
AD IN

ALC

J1450(1/3)
MIC 2

15

J1400(1/3)
MIC 1

16

MC1P

ALC

25

DA OUT

IC1401

ECHO
VOL

MIC VOL

MC2P

23

PRE
LPF

ADPCM
ENCODE

ADC

DELAY

ADPCM
DECODE

DAC

POST
LPF

S/H

MIC AMP

POOUT

29

MIC OUT

J1400(3/3)

MIC
VOL

J1450(3/3)

VOL3

VOL2

VOL1

VOLUME
CONTROL

RV1401
MIC 2
LEVEL

J1400(2/3)

RV1402
ECHO
LEVEL
RV1400
MIC 1
LEVEL

J1450(2/3)

REC-OUT-L

TAPE/TUNER
SECTION
(Page 27)

14

MIC

59

J501
L

CDG SECTION
(Page 26)

R-CH

TAPE/TUNER SECTION
(Page 27)

TAPE/TUNER SECTION
(Page 27)

CD-L

TC-PB-L

R-CH

INPUT
SELECT
SWITCH

TONE
23

28

FRONT-L

SURROUND
ST-L

24

31

R-CH

35

COMMAND

CLK

DATA

MCU
INTERFACE

30

R-CH

SW

29

R-CH

37

AMP
SECTION
(Page 29)

FRONT-R

L+R

AUDIO
IN

IC101(2/2)
INPUT SELECT SWITCH,
GRAPHIC EQUALIZER CONTROL,
ELECTRICAL VOLUME

34

53

J506
L+R
D+4V

3
2

83

84

88

: AUDIO

M61537-CLK

VACS IN

R-CH is omitted due to same as L-CH.

SIGNAL PATH

M61537-DATA

D-LIGHT
SYNC OUT

: TUNER (FM/AM)
: CD
: TAPE PLAY
: RECORD
: MIC

IC401(3/5)
SYSTEM CONTROL

HCD-GNX660

28

28

HCD-GNX660
Ver. 1.2
7-4. BLOCK DIAGRAM

AMP SECTION
IC650

IC600

POWER DRIVER

STREAM PROCESSOR

IC12
A/D CONVERTER

Signal Path

DOUT_2

DOUT 12

: AUDIO
2 RIN

BCK

BCK 11
15 SCKI

PDWN 7

31 DATA

OUTR1

36 XFSIIN
30 BCK
29 LRCK

OUTR2

21
22
23
27
18
19

14 PWM-B OUTB

SW

6 PWM-A
5 RESET

OUTA

SCDT
SCSHIFT
SCLATCH
INIT
NSPMUTE
SOFTMUTE

25
27

(+)

LPF

SUB
WOOFER

28
30

()

LPF

DC DETECT
Q865, 866

FSOCKO 37
FS0I 38

XFS0IN 48

IC11

SW

A/D CONVERTER

FRONT-R

IC500

LRCK 10

15 SCKI

BCK

DOUT1
XFSIIN
BCK1
LRCK1

PDWN 7

OUTR1

36 XFSIIN
30 BCK
29 LRCK

OUTR2

XFSIIN

HPOUTR2

6 PWM-A

5 RESET

27
28

OUTA

SCDT
SCSHIFT
XFS0OUT 14
SCLATCH
FSOCKO 37
INIT
FS0I 38
NSPMUTE
SOFTMUTE
XFS0IN 48
HPOUTL2

X001
12.288MHz

21
22
23
27
18
19

IC802
3

LPF

(+)

LPF

()

30

4
SCDT
SCSHIFT
SCLATCH 1
INIT
NSPMUTE
SOFTMUTE

14 PWM-B OUTB

OUTL1 11
OUTL2

CLOCK GENERATOR

25

R
31 DATA

IC03
1

POWER DRIVER

LRCK

BCK 11

FEED BACK
SWITCH
Q101

IC550

STREAM PROCESSOR

2 RIN

FEED BACK
SWITCH
Q151

DOUT_1

DOUT 12

1 LIN

SD

FRONT-L

43

39

DC DETECT
Q855, 856
FRONT
SPEAKER

IC530
POWER DRIVER

IC800

6 PWM-A OUTA

OSC

14 PWM-B
5 RESET
X800
49.152MHz

OUTB

28
30
25

(+)

LPF

()

27
4

IC403 (2/2)

LPF

SD

SCDT
SCSHIFT
SCLATCH2
INIT
NSPMUTE
SOFTMUTE

LRCK

LRCK 10

MAIN
SECTION
(Page 28)

XFSIIN
BCK1
LRCK1

TM1500
SW

SD

DOUT2

DC DETECT
Q850, 851

IC880

SIGNAL IN/OUT CONTROL

ADC-RESET 22
SM-NSP-MUTING 9
SM-INIT 12
SM-SOFT-MUTING 10

NSPMUTE
INIT
SOFTMUTE

J1401
PHONES
HP MUTE
Q1450,1451

HP MUTE
Q1400,1401

FAN CTRL 24

M891
DC FAN
MUTE SWITCH
Q486

IC401 (4/5)
SYSTEM CONTROL
SM-DATA
SM-CLK
SM-LATCH-1
SM-LATCH-2

78
77
76
79

SCDT
SCSHIFT
SCLATCH1
SCLATCH2

SM RESET 65
PROTECT DETECT
Q840

SM-SD 72

HP-MUTE 86
HP-DET 85

-13
MAIN ON/OFF
DELAY
Q156, 157

F
HCD-GNX660

29

29

DISPLAY/POWER
SECTION
(Page 30)

UNREG
+12V

FAN DRIVE
Q580,582,
Q584,585

HCD-GNX660
Ver. 1.2
7-5. BLOCK DIAGRAM

DISPLAY/ POWER SECTION

M+9V

DR17-35

LED+9V
D563 D562 D561

1G,
12G-16G

2-6,18

FL1300
FLUORESCENT
INDICATOR TUBE

1638

P1 20

BUFFER
Q1311-1316

IC551

M+7V

F2

AC IN

DR0-4,15

7-13,15-17

2G-11G
F1

D1100

+44V

+9V REG

IC552

AUDIO A+9V

T1300
DC/DC
CONVERTER

T1100
MAIN POWER
D1103 TRANSFORMER

+9V REG

IC1102
+12V REG

7 C

D1114

VIN 6

D1119

4 VCC

BIAS A+9V

DR5-14

D1112
SMASTER G+12V

IC1300

3 FB

IC1101

ST A+9V

VOLTAGE
DETECT

D594

POWER
SWITCHING
CONVERTER

FL DRIVER
RECT
D1300-1303

OSC
Q1300

40 VFDP

IC01

A+5V

CSb
RSTb
SCK
SI

LED +9V

D1118

IC1100

PHOTO
COUPLER
PC1100

+5V REG

51 52 48 49
+1.8V

IC810

IC02

+1.8V REG

+3.3V REG

LED+9V

MAIN ON/OFF 100

Q1308

MAIN ON/OFF
SWITCH
Q1100, 1101

-13

S1302,1306,1307,
1309-1328,1331
AD-KEY-1
|
AD-KEY-3

Q1304

D1101

C1113

D1102

Q1102

94,95,97

FL-DRIVER-CS
FL-DRIVER-RESET
FL-DRIVER-CLK
FL-DRIVER-DATA

60 59 58 57

C1112

AMP
SECTION
(Page 29)

PHOTO
COUPLER
PC1101

PHOTO
COUPLER
PC1102

D506

Q1310

D+3.3V(1)

53 LED-CTRL

Q1303

LED DRIVE
Q1305-1307

D1307-1309

50-52

FL+4V

LED-ILLUMINATION-1
|
LED-ILLUMINATION-3

D+4V

D1310-1312

ROTARY
ENCODER
S1305

+4V REG

D1212

+8V REG
Q1205, 1206

EVER +4V

+B SWITCH
Q561

CD-POWER 35
MASTER
VOLUME

IC562

+3.3V REG
Q560

+3.3V

+4V REG
Q1203, 1204

T1200
SUB POWER
TRANSFORMER

5 D

D1213

4 VCC

54 VOL-A

D1207

2 F/B

55 VOL-B

IC401 (5/5)

1 Z/C

D394

SYSTEM CONTROL
D+3.3V(2)

EVER +4V

D1204
D395

IC1201
LED DRIVE
Q1309

61 SW-LED

D393

S1301

D1313
SUB WOOFER
ON/OFF

EVER +3.3V

POWER-KEY 74
56 STBY-LED
DISPLAY-KEY 73
S1300
DISPLAY

IC1301

4 SIRCS

15 X-IN
X402
5MHz

13 X-OUT

RESET 12

RESET
SWITCH
Q213

IC402
LEVEL
DETECT

10 XC-IN
X401
32.768kHz

VOLTAGE
DETECT

Q1200

D396
PHOTO
COUPLER
PC1200

D1304

REMOTE CONTROL
RECEIVER

IC1200

D1211

AC-CUT 20
11 XC-OUT

HCD-GNX660

30

30

PRIMARY
SWITCHING,
MAIN
CONVERTER

HCD-GNX660
See page 25 for Circuit Boards Location.

7-6. PRINTED WIRING BOARD BD84 BOARD

"

: Uses unleaded solder.

&

'





)
BD84 BOARD (SIDE B)
BD84 BOARD (SIDE A)
M101
(SPINDLE)

C302

IC303

S101
(LIMIT)

C305
C303
R405
R419 R403
R351

16

C308

C116

33

R407

R411
OPTICAL PICK-UP
BLOCK
(KSM-215DCP)

TP124
(RFAC)

R151
C132
R143 R141

C123

C124

11
(11)
C122

R133

C143

MAIN
BOARD
CN351
(Page 35)

C185

C186
C161

R203

R204

R421

R111

R161

C162

C18
R11
R12
E

R10 R13

C134

R181

C111

1-864-566-

R182

C194

IC101

CN101
C16
Q10

R121

R112

C10
C11

C15

C125
C151

C181

C114
C113
R113
R114

C14

R173

R171
C171

X171

C17

C115

C112

C209

R406

JPO103
(TE1)

JPO102
(FE1)

C195

C163

R132
C133

C172

CN201

R412

R172

C203

R409

R131
C131

C201

C182

TP117
(VC)

R402
R401

R410

R191

C174

R201

R162

C196

C183

R165

C210

48
R303 C310
R163

C251

C184

R205

C317
R305

49

R252

R251

FB301

IC301

32

C318

M102
(SLED)

64

R307

C307
C320

C259

C309

R253

C258

R306 R301

17

IC251
C312

C213

R352

C314

C313

C211

R354

R302

C306

C311

R353

R408

C257

C212

C260

R313

C316

R404

C252

C255
C315

R422

R423

R142
C141
C142

1-864-566-

11
(11)

Semiconductor
Location

Ref. No.

HCD-GNX660

31

31

Location

IC101
IC251
IC301
IC303

E-9
C-7
C-9
B-10

Q10

F-4

HCD-GNX660
7-7. SCHEMATIC DIAGRAM BD84 BOARD See page 53 and 54 for IC Block Diagrams. See page 25 for Waveforms.

See page 56 for IC Pin Function Description

R131
1M

C307
0.1

C143
0.1

R307
10k

R121
15k
C134
0.1

C131
100p

C142
0.0015

R143
3.3k
C308
47
4V

C151
100
10V

R352
100
R354 100
MP3REQ

R405 100
R404 100

R303
100k

R302 10k

R419 100
R403 100
C310
0.1

C309
0.1

R301
100k

R305
100k

R402
100

R133
180k

R132
10k

R142
1k

R141
4.7k

MIACK
MICK
MIDIO
MILP
MICS
MP3STB

R13
1

C17
220
4V

C125
0.1

R10
3.3

C16
1

JPO10
APC
TP124
(RFAC)

CN101
16P

Q10
2SA2119K
LD DRIVER

C15
0.1

R11
0
C18
0.001

C132
0.47

R353
100

R351
100

R12
100k

C133
0.01

C141
0.1

R151
0

C123
0.1

C124
330p

C10
10

C11
10

C122
0.1

R203
0

D
C
B
A

C320
0.001

C318
0.01

C161
0.1

R111 1k

C317
0.01

JPO102

FEI

JPO103

TEI

C111
C112
C113
C114

R112 15k

MP3RST
IC301
TC94A34FG-002

R313
220

C316
0.0022

MP3 DECODER
C311
0.1

R113 1k

R401
100

R306
0

C306
0.1

C162
0.1

C315
0.1

C312
0.1

C313
0.1

C172
27p
X171
16.9344MHz

C174
0.1

C314
47
4V

IC303
BH15FB1WG

C14
0.1

E
D
A
B
C
F

C171
22p

R114 15k

0.0033
470p
0.0033
470p

F
E

C115
0.1
C116
100
10V

IC101
CXD3059AR

R171
470

R172
1M

TP117
(VC)

RF AMP, DSP, DAC

R173
0

REG

C185
470p

R181
100

C186
470p

R182
100

C183
22
6.3V
C184
22
6.3V

R252
22k

R251
10k
C305
220
4V

C303
0.1

C302
0.1

FB301
0uH

C181
0.1

C251
0.0068

S101
(LIMIT)

IC251
BA5947FM-E2

C182
0.1
C194
0.1

R253
10k

C209
0.01

R205
0

MP3RST
100
100
100
100
100
100
100

C203
100
10V

SCOR

SENS

XLT
CLOCK

DATA

C201
100
10V

M101
(SPINDLE)

SCOR
SENS
CLOCK
XLT
DATA
XRST
XTACN

C252
0.1

C211 220p

R201
0UH
C260
220
10V

R204
0UH

R423 100
R421 100

C257
0.1
M102
(SLED)

C212 22p

C213 22p

C259
0.1

C196
0.1

MIACK
MICK
MIDIO
MILP
MICS

R411
R410
R409
R408
R407
R406
R412

C195
0.1

R163
100

XTACN

MP3STB
MP3REQ

MAIN
BOARD
(1/3)
CN351
(Page 36)

C210
0.1

SBSO
EXCK
XRST

R162
47k

C258
0.1

R191
0

C163
0.1

CN201
31P

SL/SP MOTOR
DRIVE

JPO004
MDP

R165
0

WFCK

R161
100

WFCK
SBSO
EXCK

R422
100

HCD-GNX660

32

32

C255
0.1

HCD-GNX660
7-8. PRINTED WIRING BOARDS CD MECHANISM SECTION

See page 25 for Circuit Boards Location.

: Uses unleaded solder.

SENSOR BOARD
A
CN731

DRIVER BOARD

D711

1
CN704

1 CN703

C731

1-687-669-

12
(12)

D701
9

JW714

R721

R722

R702

CN751

IC701

JW713

C737
C736
C735

1-687-134-

C751

R723

R701

12
(12)

R731

JW703
JW702

2
1

JW701

CN742

R713

R712

M741
(TABLE)

CN702

R735

S751
(OPEN)

IC712

R711

CN741

JW708
JW709

C741

R734

JW710

C715

R736

R732

SW BOARD

CN701

JW704

MOTOR(TB) BOARD

JW707
JW706
JW705

R733

12
1-687-132- (12)

C752
JW712

2
1

JW711

CN705

IC731

R751

Q731
E

MAIN BOARD
CN511
(Page 35)

1-866-201-

12
(12)

MOTOR(LD) BOARD
D
1

S711
ROTARY
ENCODER

CN721

Semiconductor
Location

Ref. No.

M751
(TABLE LOADING)

1-687-133-

12
(12)

HCD-GNX660

33

33

Location

D701
D711

C-5
C-5

IC701
IC712
IC731

C-5
B-5
B-2

Q731

B-4

HCD-GNX660
See page 53 for IC Block Diagrams.

7-9. SCHEMATIC DIAGRAM CD MECHANISM SECTION

IC701
BA6956AN

M751
(TABLE LOADING)

CN721
2P

C751
0.01

CN704
2P

R702
100
R701
470

D701
MTZJ-T-77-5.1A

IC712
BA6956AN

IC731
RPI-576
M741
(TABLE)

CN731
3P

CN742
5P

C741
0.01

CN702
5P

R711
1k

CN741
3P

D711
MTZJ-T-77-3.6B

R712
4.7k

C715
100
16V

R713
22k

CN701
13P

R736
390

CN703
4P

MAIN
BOARD
(1/3)
CN405
(Page 36)

E1
E2
E3

R731 100

CN711
4P
R733
1k

R734
12k

R732
10k
Q731
DTC114ESA
INVERTER

R723
4.7k

R722
4.7k

R721
4.7k
C731
10
50V

C737
0.1

C736
0.1

C735
0.1

R751
4.7k
C752
0.1

CN705
2P
S751
(OPEN)
CN751
2P

HCD-GNX660

34

34

HCD-GNX660
Ver. 1.2
See page 25 for Circuit Boards Location.
4

JW167

R563
JW166

JW165

JW164

JW163

JW186

JW184

JW183

JW185

C527

JW188

R531

C537

JW193
JW192
JW191

C523

JW182

JW181

C535
JW161

JW159

JW201
JW202
JW203

C570

JW239

ADC
BOARD
CN01
(Page 43)

JW250

C553

C582

JW252

JW253

JW255
JW254

R506

35

35

2
1

4 5
3

R509
R508
JW382
FB514
CLP02

JW391

C550

EP501

JW592
JW385

JW257

JW256

JW261

JW262

JW258
JW388

CN590
7

POWER
BOARD
CN1200
(Page 51)

M891
DC FAN

CN580

JW247

JW244
JW245
JW246

HCD-GNX660

R575

JW249

JW243

JW263

JW264

R525

C521

C556

D581

JW393

IC552

Q582
E
E R578
E
Q580
Q584
R576
R583
3
C580
E
Q585
1
JW248
R577

JW238

D583

C583

JW399

D594

C555
C554

JW242

R246

JW371

D582

JW236
JW237

JR037

D580

IC551
C551

R580
R579

C552

JW241

D561

FB513 C581

JW231

R294

JW233

C520

D562

JW232

JW265

JW226

FB505

JW230

Q287

JW234

JW259
JW260

Ref. No.
J501
AUDIO IN

C531

D563

C267

JW266
JW267

C571

JR550

JW228

JW288

R267

Semiconductor Location

FB555

JW205
JW204

JW207
JW206

JW209
JW208

JW210

JW215
JW214
JW213
JW212
JW211

JW194

JW381
JW220

JW219
JW218
JW217
JW216

JW155

JW299
JW298

JR126

JR381

JW227

JW287

JW281
JW279
JW280
JW278

JW270

JW199

JW221

JW222
JW223

JW240

JR267

JW268

JW271

FB506

JW100

JW101

JW098

JW099

JW094

JW093

JW090
JW091
JW092

JR020
JW124
JW153
JW379

JW152

JW146

JW147

JW355

JW145

JW321

R200

JW274

IC562

1-868-829J

R398

Q157

R524

R245
JR036

JW322

JW162

R488

JW307

JW377
JW372

C197

C497
JW403

JW196

JW286

JW285
JW283

JW277

JW332

JR057

JW195

CLP04

R296

JW289

JW282

Q114

Q156
E

CLP05

JW235

C105

JW333

JW334

JW335

JW295
JW294

JW317
JW318

JW329

JW273
JW331
JW396
JW330

JW336
JW338

JW337
JW378

JW339

JW291
JW290

JW316

JR029

R399

NO012

R295

JW315

CN381

R149

JW296

JW313

C133

R500
C568

BC E

R560

CDG
BOARD
CN1003
(Page 49)

-13

Q560

Q237

JW328

C192
JW272

C194

-12

C567

JW200

JW386

JW314

C166
R133 C198

R155

R192
R191

C189

Q561

JW224

JW293
R244
JW292 E

JR261

JW326

C193

C190

C238

JW312

E
Q151

JW190
NO560

D586

C288

JW310

R157

E
C116

JW102
JW103
JW104

JW077
JW089

JW076

JW075
JW086
JR049

JW128
JW127
JW126

JW300

JW311

JR043

JW189

JW398

JW301

JW297

JW269

C164

R169
C165
R156
C160

JW324
JW325
C188

C191

C113

R116

R106
C114
R109 R119
C115

C110

R167

JW369

C185

C135
C109
C108
C111
R108

JW358

JW340 JR042

Q113

C163

B502

R574

C154

JW320
JW319

R532

JW390

CLP01

JW044

JW160

JW229

JW158
JW157
JW156

JW394
JW380

E C142
R146

JW125

JW085

JW084

JW082

JR153
JW302
JW142
JR152
JW143
JW144
R483

JR019
JW376

JW370

R162

R152

R153

R199
C184

R168

R158
R166
C162

C161

C187

R193

Q101

Q308

L105

JW284

JW309

Q307 JR028
E

R148

C141
R145
Q112
BC E

JW149
JW150
JW151

JW308

C150

C522

R582
JW187

JR046

JW384

JR176

C158

C534

JW171
JW170
C547
JW169
JW168

B501
JW502

C539

R581

JW173

31
30

JW123

JW118
JW119
JW120
JW129

JW303
JW304
JW305

C153

FB509 JW175
FB510

CN351

JW323

R190 C186

JW180

JW179
JW178
JW177
FB512
JW174

JW121
JW122

C177

C151

JW501

JR024
C538

FB507

JW500

CN406

JW110

JW306

JR022
R139

R194

R105

13

JW198

JW148

C159

C112

JW087
JW088

JW073

JW072
D396
D393

JR017

JR015

JR018
R484

JR481

JW134
JW383
JW136
JW137
JW138
JW139
JW140

C585

CN111

C157

JW275
JW374

C308

E
JW375

R163

E
Q486

JW068

(FOR CHECK)

Q153

R161
C171
JW366

JW357
JW327

R195
R118
R150

C307 JW341
R311 R310

Q302

JR047

C301 R301

R144
C140

T101

C148

E Q301
E

R312

C302

L104
JW342

R126
C126
C138

R176

R587

E
Q125

R117

C147

JR032
R304

R141 R140

Q107
C124

Q304

R305
R584
R590
C303 R302
R592 R585
E
Q175 E
R303 R147

R591

R188

JW112
JW113
JW114
JW115
JW116
JW117

JR044

JR026

R151

R160
C168

12

TUNER
PACK

JR048

JW176
FB508

C536

JW107
JW108
JW109

JW111

-12

1 CN205

R486 5

D486
C486

C180

IC101

Q303
E JW346

C304

JW081

JW079

D232

JW130

C122

C104

C176 R175 R142

R308

JW347

C172

R231

JW133

NO013

C101

C195

JW352
JW351
Q108
E Q109
E

JW080

D216

JR050
R215
D231

JW132
R385

JR014

R207
R205

JW364

C106

C120
JW363
R111 R102

C121
R112

JW356

8
CN131

R164

C139

R586
JW344
C200

JW069

JW066

JW067

R424
JW064
JW065
JW063
JW058

R394
R395

JW057

JW055
R392
JW056

JW131

JW052
JW053
C416
JW054

R489

R490

R227

JR016

JR228

R230

R482

R412

C410

JW033

JR487

JW035
JW034

C202

C204

JW039
JW038

D230
C230

JW365

R159
R110 C134

C107

C125

R593

C136 JW367

R189

JW354

R143
JW343

JW345

C103

C170
C169

R198

FB104

R172

R114

Q103

C130
R138

C123
JR055

CLP03

FB102

Q155 R122

L103

JW368

11

C526

C546

JW105
JW106

JW083

R406

JW276
JW395

R338

JW061
JW062

JW353

JR021

R397
R478

JW019

JR008

R491
R225

R407

JW141

R209

JR030

R501

R448
R447
R446
R445
R444
R443
R442

JW036

C132

R101

JR031

Q154
E
Q104
E
Q105
E
R173
R123
E

JW078

JR027
CN121 FB103
C137
1
FB152
3
C156
FB153
JW360
C118
R165
C119

Q111

Q106

R125
R127
C179
C178
C199
R177

R485
JR013

CN105

R306

R497

JR033

R128

R495

R476

C228

JW051

Q110

Q166
R174
R124

R479

D213

R494

R493

R492

R477

C214

C216
R405
R403
R402 R401
R500

R404

JW032

R103

JW049

R131

TAPE B
HEAD

IC402

D215

CLP06

JW046
JR012 JR011 R115
JW047
R104
R107 R121

TAPE A
HEAD

R393

JW031

4 5

C215

R129

FB151

SMASTER
BOARD
CN500
(Page 45)

JW030

R513

CN321
JW074

JW045

JW048

R120

JW042
JW135

CLP07

TAPE
MECHANISM
DECK

R130

CN101

JW041

D395
E

Q213

JW037

D101

JR004

C201

IC403

JR056

JW043

R202

R220
R221
R222
R224

Q120
ECB
D102 E B
C
Q122

R212
R210

ECB

JR006
JR005
R204
JR009
JW029 JR007
R203
C203
R196
R197
C145

Q123
E

R184

C496

R512
13

R422

C414 3 1

80 81

JW027
JW028
JR480
JW475

R374

R372

Q121

C412

JR051

C498

R474

JW040

Q118

R473

R182

D104 C144 R179

R178

IC401

C462

D394

C411 R309
X401

BD84
BOARD
CN201
(Page 31)

R511 R510

R423

JW060
JW059

JR318

100

C464

R373

R181

R180
R183

JW017
R226 JW018
E

Q119

51

R465

C226

X402

50

JW362
JR059
C173 JW361
FB101
JW359
R113

JR467

R419

R413
R411

JW050

R463
JW016

R420

R432 JW025
JW026

31 30

C175
C174

JW389

JW251

R428

R450
R451

R186

PANEL
BOARD
CN1402
(Page 39)

R425
R421

R433

R459
R461
R455
JW012
R453
JW471 JW013
R452
JW014

R456
R457
R458
R460

JW004
JW005
JW006
JW007

R472
JW015

JW008

R439
R435

R337

C499

JW009
R355
R354 JW010
JW011
R454
R431 R329

JW003

CN201 NO011

R437

10

CN405

JW373

R436

MIC
BOARD
NO1401
(Page 41)

CDG
BOARD
CN1001
(Page 49)

C504

R340 D506
R440

R417

JW002
R330

JW020
JW022
JW021
R438 JW023
R430
R429

JW001

NO401
4

JW070
JW071

JR002
R341
JW024
R441

(FOR CHECK)

R427
R426

(FOR CHECK)

R449

CN402

-13

JR003

MAIN BOARD
JR001

DRIVER
BOARD
CN701
(Page 33)

G
A

: Uses unleaded solder.

D214
C213
R214 R216

JW095
JW096
JW097

7-10. PRINTED WIRING BOARD MAIN BOARD

11 11
(12) (13)

J506
D-LIGHT
SYNC OUT

Location

D101
D102
D104
D213
D214
D215
D216
D230
D231
D232
D393
D394
D395
D396
D486
D506
D561
D562
D563
D580
D581
D582
D583
D586
D594

E-3
E-2
E-2
C-6
C-5
C-6
C-5
D-6
D-5
D-6
C-6
B-5
C-5
C-6
D-6
B-4
F-11
F-11
F-11
G-12
G-12
G-11
G-12
C-11
G-10

IC101
IC401
IC402
IC403
IC551
IC552
IC562

G-5
C-4
C-5
E-3
G-11
G-11
D-11

Q101
Q103
Q104
Q105
Q106
Q107
Q108

H-5
G-3
H-2
H-3
G-2
H-3
H-3

Ref. No.
Q109
Q110
Q111
Q112
Q113
Q114
Q118
Q119
Q120
Q121
Q122
Q123
Q125
Q151
Q153
Q154
Q155
Q156
Q157
Q166
Q175
Q213
Q237
Q287
Q301
Q302
Q303
Q304
Q307
Q308
Q486
Q560
Q561
Q580
Q582
Q584
Q585

Location
H-3
F-3
G-3
I-4
I-4
I-4
D-2
D-2
D-2
D-2
E-3
D-2
I-3
G-6
F-5
G-2
H-2
D-13
D-13
G-2
I-3
C-5
G-8
F-9
H-4
I-4
H-4
H-4
H-4
I-4
D-7
C-11
D-10
G-11
G-12
G-12
G-12

HCD-GNX660
Ver. 1.2
7-11. SCHEMATIC DIAGRAM MAIN BOARD (1/3)

BD84
BOARD
CN201
(Page 32)

CDG
BOARD
CN1003
(Page 50)

CDG
BOARD
CN1001
(Page 50)

40

ST-R

38

39

36

37

27

R582
0

CN205
5P

35

25

26

C539
0.1

JW390

R532 0

C535
1000
10V
D563
10EDB40

ST-L

FB506 0uH

1
C534
0.1

C523 220p
24

CN406
9P

D562
10EDB40
D561
10EDB40
5

FB508 0uH

FB507 0uH

C526 0.1

C522 220p

22

23

C546 220p
19

82

21

C527 220p
2

28

19

34

28

33

35

C547 220p

FB509 0uH
C538 0.1

WFCK

EXCK

SBSO

FB512
0uH

WFCK

DGND

EXCK

SBSO

GND

R513 1k

31

WFCK

R512 1k

R511 1k
EXCK

CN351
31P

-13
32

470 10V

31

CN405
13P

SBSO

R510 1k

C504
1000 10V -12

NO560
2P

FB510 0uH

13

VCC

SCOR

SBSO

WFCK

MUTE-DATA

EXCK

PAL/_NTSC

_HALT-CLK

CDG/_BGC

_CDG_RST

CDG-POWER

CDG-DET

DGND

CN321
13P

VMUTE

49
48
47
46
45
44
43
42

DRIVER
BOARD
CN701
(Page 34)

MIC
BOARD
NO1401
(Page 42)

IC562
TA7804LS

JR176
0

D506
1SS355W

MIC

C537
0.1

C536
0.1

JR126
0

Q560
RT1P137P-TP-1
BD +3.3V REG

IC562
+4V REG

41

C238
10
50V

NO401
4P
R244
2.2k
(FOR CHECK)

29
30

R245
47k

CN402
10P

C567
0.1

R294
2.2k

R246
10k

33
32
9
12

R560
2.7k

C520
10
50V

TV/SAT-L

R563
1k

Q561
DTC114EKA
B+ SWITCH
TV/SAT-R

R486
2.2k

Q287
2SC3661
MUTING

D486
1SS355W
86
C486
470
16V

R296
10k

Q486
DTC114EKA
HP MUTING

C521
220p

R525
100k

C571
220p

R575
100k

R509
4.7k

CD-L

CN381
17P

R508
5.6k

I/O 24

IC551

D582
1SS355W

+9V REG

JR267
0

FB514
0uH

R579
3.3k

Q584
DTC114EKA
BUFFER

R577
100k

0uH

Q585
2SD2525

R580
3.3k

M891
DC FAN

D581
UDZ6.2B

C581
0.1

C580
0.1

Q582
2SC2412

R578
4.7k

D-LIGHT
SYNC OUT

CN580
3P

Q580
2SC2412
R267
0

C552
470
10V

C267
10
50V

C555
0.1

C583
4.7
50V

C551
1
50V

D583
UDZ6.8B

R576
47k
Q580,582,585
FAN MOTOR
DRIVE

D580
1SS355W

I/O 22

JW226
D594
10EDB40

J506
FB513

IC551
TA7809LS

ADC
BOARD
CN01
(Page 44)

R
FB555
0

R506
10

R583
3.3k

J501
AUDIO IN

R574
1k

L+R_LIGHTING

C531
0.1
L

C570
10
50V

JR550
0

R488 2.2k

FB505
0

R524
1k

85

CD-R

(FOR CHECK)

C568
1000
6.3V

R295
47k

Q237
2SC3661
MUTING

31
34

C288
10
50V

D586
10EDB40

C550
4700
16V

CN590
7P
JW391

IC552
TA7809LS

JR261
0

IC552

C582
4700
16V

+9V REG

JW592
POWER
BOARD
CN1200
(Page 52)

JW385
C554
470
10V

C556
0.1

C553
1
50V
EP501

MAIN
BOARD
(2/3)
(Page 37)

MAIN
BOARD
(3/3)
(Page 38)

HCD-GNX660

36

36

EVER+4V

FAN DET

D+4V
GND

M+9V
BD MGND

FL+4V

E
D+3.3V
G

EVER+3.3V

GND
AUDIO+9V
FRONT-R
FRONT-L
B
A
VRSW
CD MUTE

100

HCD-GNX660
Ver. 1.2
See page 25 for Waveforms.

7-12. SCHEMATIC DIAGRAM MAIN BOARD (2/3)

See page 59 for IC Pin Function Description

I/O 19

R182
3.3k

Q121
DTC114EKA

I/O 18

R407 100

C410 22p
X401 32.768kHz

R183
3.3k

R413 0

R184
3.3k

R417 10k

D102
1SS355W

JR318 0

R181
680

R411 330k

R430
R429
R428
R427
R426
R425
R424
R423
R422
R421
R420
R419

100
100
100
100
100
100
100
100
100
100
1k
100

Q120,121
CAP MOTOR
DRIVE

C412
0.1 C411
18p

3
2
1

R406 100

R412
100k

Q120
2SB1132-T100-QR

7
R309
10k

R330
10k
R306
4.7k

100
100
100
100
100

Q119
DTC114EKA

R197
680

C145
0.0047

R196
2.2k

Q122,123
A TRIG
DRIVE

R186
2.2k
I/O 17

Q123
DTC114EKA

CN101
11P
R104 47k

R337
10k
R338
10k
R340
10k
R341
10k

R107 4.7k
R120 4.7k

R115 10k

91
90

R121 3.3k

R435
R436
R437
R438
R439
R440
R441
R442
R443
R444
R445
R446
R447
R448
R449

38
39
40
41
42
43
44
45
46
47
48
49

100
R497
220

100
100
100
100
100
100
100
100
100
100
100
100
100
100
100

R493 4.7k
IC401
M30622MGP-A54FPU0

91
90
89

R491 100
R490 100
R489 100

IC401

R393
1k

R492
150

R397
3.3k

R495
220

R395 3.3k
R394
3.3k
D230
1SS355W

R494
220

86
85
R484
R483

100
100

84
83

R485
100

82

C230
2.2
50V

JR381
0

R227
0

R231
47k

CN105
19P

D232
1SS355W
79

R472 100
R473 100
R474 100

JR467 0

R372 10k
R373 10k

R374 10k
R476
R477
R478
R479

100
100
100
100

R465 100

R463 100

78
77
76

JR480
0

SMASTER
BOARD(1/2)
CN500
(Page 47)

65
72

D394
1SS355W

73
74

I/O 9
I/O 10

JW475 0

JW471 0

51

50

C462
100
10V

59
60
73
74
61

R482
100

R230
100

D393
1SS355W

59
60
61

50
51

53
54
55

R354 10k

94
95
97
4

R355 10k

R451
R452
R453
R454
R455
R456
R457
R458
R459
R460
R461

100
100
100
100
100
180
100
100
100
100
100

CN201
25P

I/O 12

63

C464 0.1

R205 100
R207 100

R209
100

20

12

I/O 12

R203
100

C203
100p
C202
0.01

R210 100

I/O 5

I/O 7

D
I/O 9
I/O 10

C204
100p

D396
1SS355W

34D

R204
100
R202
100

D395
1SS355W

76
77
78
79

72

65

PANEL
BOARD
CN1402
(Page 40)

R385
10k

D231
1SS355W
R225
33k

53
54
55

95
94

JR487 0

R450
100
63
89

97

R392
4.7k

SYSTEM CONTROL

JW135

R130 47k
R131 3.3k

Q157
2SC2712
R398
220k

C496
10
50V

R500
100 -12
1K -13

R128 22k
R129 4.7k

Q156
2SC2712

C497
1
50V

C498
0.1

C499
0.1

R431 100
R432 100
R433 100

31
32
33
34
35
36
37

Q156, 157
MAIN ON/OFF R501
4.7k
DELAY

R399
100k

Q122
2SB1132-T100-QR

D101
1SS355W

-13

C416
3300
6.3V
C414
0.1

R405
R404
R403
R402
R401

R180
2.2k

X402
5MHz

R329
10k

R179
2.2k

30
29
28
27
26
25
24
23
22
21
20
19

R178
Q118
680 2SB1132-T100-QR

C144
0.0047
D104
1SS355W

12

Q118,119
B TRIG
DRIVE

DBFB FEEDBACK
VACSIN
GND
VP

R215
1k
D214
1SS355W

R212
100

D215
1SS355W

IC402
IC PST3629NR

C201
100p

IC402
LEVEL DETECT

IC403
BH2210FV

R216
220

D216
1SS355W

C216 0.1

IC403
SIGNAL IN/OUT
CONTROL

Q213
DTC124EKA
RESET
SWITCH

HCD-GNX660

37

C213
0.1

C215
10
50V

FAN DET

C214
0.1

D+4V

GND
MAIN
BOARD
(1/3)
(Page 36)

37

D213
1SS355W

I/O 22
I/O 21
I/O 20
I/O 19
I/O 18
I/O 17

R222
100
I/O 24

C226
100p

EVER+3.3V
G

D+3.3V

BD MGND
M+9V

FL+4V

R226
100

R214
0

EVER+4V

R224
100
C228
100p

R221 100
R220 100

JR228
0

MAIN
BOARD
(3/3)
(Page 38)

HCD-GNX660
Ver. 1.2
See page 25 for Waveforms.

C198
2.2
50V

C180
0.0056

FB153
0
Q166
2SC3661
MUTING R174
2.2k

R172
2.2k

Q155
2SC3661
SWITCH
Q105
2SC3661
SWITCH
Q104
2SC3661
SWITCH

R590
C199 10k
0.0022

C174
120p
C175
330p

R114
0

R175
27k

R125
27k
C126
0.001

C176
0.001

R126
4.7k

R176
4.7k

C178
0.01

C136
100
16V
C585 0.1

R142
10k

C119
10
50V

C124
120p

C200
0.0022
C125
330p

R147
33

R592
100k

R101
180

R113
10k

R145
10k

C138
0.0047
C140
47
35V

R191 470

R194
4.7k

C191
0.18

C122
10
50V

C192
1 50V

R111
1k
C101
10
50V

R138
47k

C104
10
50V

R189
0

R118
15k

C103
10
50V

C195
1
50V

R195
1M

R150
47k

R117
2.2k

C148
2.2
50V

R149
4.7k

Q302
DTC114EKA
R301
10k

C302
2.2
50V

R303
100k

C304
2.2
50V

R302
22k

Q303,304
TC MUTING

Q307
DTA124EKA

Q304
DTC114EKA
C303
2.2
50V

C301
2.2
50V

R146
10

Q303
DTA124EKA

Q308
DTC114EKA

R304
15k
C307
2.2
50V

R308
470k

C308
2.2
50V

R305
68k

HCD-GNX660

38

38

Q307,308
CD MUTING

R310
15k
R312
470k
R311
68k

Q101
2SC2412
SWITCH

C111
0.033
C109
0.027

R116
10k

R108
2.2k
C110
10
50V

Q301,302
TC REC MUTING

Q114
DTC114EKA
SWITCH

C113
10
50V

C116
4.7
50V

R106
5.6k
R109
18k

R584
5.6k

Q301
DTA124EKA

R119
470

C114
0.68

L105
100uH

I/O 20

C139
0.01

R144
47 C141
0.01
C142
0.0068

C115
0.56

C121
1
50V

Q125
2SC3661
REC MUTING

I/O 21

T101

R103
10k

C147
0.0047

R587
47k

R593
100k
Q113
RT1P137P-TP-1
SWITCH

Q112
2SD596T1
BIAS OSC

C135 100p
R110 330k
C120 R102
0.01 2.2k

Q103
2SC3661
MUTING

R148
47k
R143
3.3k

R193 4.7k

C134
100p

C130
0.0056

TC-L

R585
47k

R586
5.6k

C179
0.01

R192 470
C189 220p

C190 220p

R112
10k

Q175
2SC3661
REC MUTING

R591
10k

C166
4.7
50V

C193 0.18

Q109
DTC114EKA
BUFFER

R127
5.6k

L103
27mH

R160 330k
C185 100p

C118
470p

Q108
DTC114EKA
SWITCH DRIVE

R177
5.6k

R169
470

C165
0.56

C132 100 16V

R123
2.2k

L104
27mH
R164
0

R140
10k

R122
2.2k

C171
1
R153 50V
10k

R133
1M
C133
1
50V

R156
5.6k

C184 100p
Q111
DTC114EKA
SWITCHI DRIVE

R141
10k

R173 2.2k

C168
C170 R152
470p
R151 0.01 2.2k
180

R155
47k

Q151
2SC2412
SWITCH

C164
0.68

C108 0.027

Q154
2SC3661
SWITCH

C169
10
50V

R199
0uH

Q107
2SA812
SWITCH DRIVE

FB151
0

FB104
0uH

R124
2.2k

Q106
2SC3661
MUTING

C172
10
50V

C107 0.1

C123
220p

C162
0.0047 -12
0.0068 -13

R157
18k

34D

FB102
0uH

C137
470
16V

IC101
INPUT SELECT SWITCH,
PB/REC EQUALIZER AMP,
GRAPHIC EQUALIZER CONTROL,
ELECTRICAL VOLUME

C163
10
50V

TV/SAT-L

C173
220p

R159
0uH

R168
15k

R190
10k

ST-L

CN131
8P

Q110
DTA114EKA
MUTING
SWITCH

I/O 7

FB101
0

R162
10k

C186
0.068

R139
0

C151
10
50V

R161
1k

C154
10
50V

R158
2.2k

R166
10k
C161 0.033

C153
10
50V

TC-R

R165
0uH

C156
680p

FB152
0uH

C177
0.47

C158 0.027

R198
0uH

IC101
M61537FP-RFOG

R167
2.2k

C159 0.027

C106
680p

FB103
0

R188
47k

I/O 5

CN121
3P

C105
10
50V

C150
10
50V

C157 0.1

R163
10k

C160
10
50V

R200
47k

C197
0.0047

Q153
2SC3661
MUTING

C112
0.0047 -12
0.0068 -13

A+4.5V

R105
47k

C194
10
50V
C187
100
10V
C188
0.1

83
84

CD MUTE

GND
AUDIO+9V

B
A
FRONT-R

VP
VACSIN
DBFB FEEDBACK
D

TC-R

L+R_LIGHTING

TC-L

MIC

(FOR CHECK)

ST-R
CD-R
TV/SAT-R

CN111
3P

MAIN
BOARD
(1/3)
(Page 36)

CD-L

GND

MAIN
BOARD
(2/3)
(Page 37)

VRSW
FRONT-L

7-13. SCHEMATIC DIAGRAM MAIN BOARD (3/3)

HCD-GNX660
Ver. 1.1
7-14. PRINTED WIRING BOARDS PANEL SECTION
3

See page 25 for Circuit Boards Location.

4

PANEL BOARD

10

C1357

C1316
JW1331
JW1333

D1304

CD

JW1300
JW1329

JW1345

JW1309
R1330

JW1346

Q1304
JW1347
JW1348
C1301

L1300
D1303

JW1307
S1322
TUNER/
BAND

R1331

D1302

R1303

D1300

R1301

S1300
DISPLAY

R1304
JW1350 JW1353

D1301

C1304

JW1378 Q1306
E
C1300
Q1305
JW1366
JW1367
JW1364
C1302
E
Q1307
JW1365

Q1300
1
5
2
3
R1300
JW1349

D1305

T1300
JW1308

S1321

JW1301

S1309

ILLUMINATION/
SUB WOOFER LEVEL

TAPE
A/B

I
S1307

IR BOARD

S1310
X

CN1403 3

S1326
ALBUM +
M

C1308

R1306

JW1371

S1323

JW1305
JW1306

R1305

VOL
BOARD
NO1402
(Page 41)

R1313

JW1304

JW1380
JW1379

CN1452

SUB
WOOFER
ON/OFF

R1311
Q1309

R1317

JW1368

JW1358
JW1361
JW1362

S1302

JW1303

R1332

JW1370

R1327
R1326

D1306

JW1334
JW1335
R1348

B
C
E

R1345
Q1310
E

JW1363
S1327
REC PAUSE
START

R1314
D1313

C1306

JW1369

JW1377
JW1376

Q1308
E

Q1311

R1308
JW1322

R1347

Q1303
E
C
B

JW1372

S1311

JW1342

C1305

S1324
CD SYNC

R1328

Q1312

R1346

JW1392
JW1395
JW1393
JW1394

Q1314 Q1313
E
E

Q1315
E

S1301

JW1302

CN1453

JW1383

JW1374
JW1375
JW1384

S1312
DISC SKIP
EX-CHANGE

C1310
R1307 52 1
R1353
C1314
C1315
R1355

14
13

R1302

JW1352

S1313
DISC 3

IC1300

R1321
JW1388

JW1351

R1322

CN1402

JW1354
JW1355
JW1356
JW1390
JW1391

R1361

JW1360
JW1359
JW1357

JW1386

S1314
DISC 2

C1312
C1313
R1352

JW1387

R1323

R1324

39
40

R1351

D1314

JW1344
JW1343

C1311
S1315
DISC 2

R1356

27 26

Z
OPEN/CLOSE

JR1305
R1318
R1320
R1319

C1317
JW1310 C1318
JW1320
JW1311 C1319
JW1336
R1360 JW1312 C1320
JW1313 C1321
JW1382
JW1337 R1359 JW1314 C1322
JW1315 C1323
JW1316 C1324
JW1338
JW1317 C1325
JW1318 C1326
R1358
JW1321 C1327
JW1339
R1357
JW1319 C1328
JW1340
JW1323 C1329
JW1324 C1330
JW1341
JW1328 C1331
C1309
JW1330

FL1300
FLUORESCENT Q1316
JW1381 INDICATOR
TUBE
E

C1307

S1316

MAIN
BOARD
CN201
(Page 35)

: Uses unleaded solder.

Semiconductor
Location
Ref. No.
D1300
D1301
D1302
D1303
D1304
D1305
D1306
D1313
D1314
IC1300
IC1301

B-5
E-7

Q1300
Q1303
Q1304
Q1305
Q1306
Q1307
Q1308
Q1309
Q1310
Q1311
Q1312
Q1313
Q1314
Q1315
Q1316

C-8
C-5
C-6
C-6
C-6
D-6
C-5
B-10
C-5
B-8
B-7
B-7
B-7
B-6
A-6

TV

IC1301
3

11
1-868-934- (11)

S1317
x

S1325

S1320

ALBUM M

DIRECTION/
KARAOKE

R1325

1-868-830-

HCD-GNX660

39

39

Location
D-7
D-7
D-7
D-7
A-10
D-7
B-10
B-10
B-4

11
(12)

HCD-GNX660
7-15. SCHEMATIC DIAGRAM PANEL SECTION

L1300
47uH
R1300
3.3k
IC1301
RPM7240-H9
C1300
22
50V

IC1301
REMOTE CONTROL
RECEIVER

T1300
(DC/DC
CONVERTER)

Q1300(1/2)
CPH5504
OSC
1

D1305
RD6.2FM

C1302
0.01
C1304
220
50V

D1301
1SS355WTE-17

R1301
22k
R1302
22k

D1302
1SS355WTE-17

C1301
0.022

D1300
1SS355WTE-17

4
3

C1306
0.01

FL1300
FLUORESCENT
DISPLAY
TUBE

R1305
2.2k
1W

R1304
100
R1303
100

D1303
1SS355WTE-17
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
26
27
28
29

33
34
35
36
37
38
39
40
41
42
43
44
45
46
47
48

C1357
0.1

C1308
0.001
CN1403
3P

CN1453
3P

C1309
47
16V

D1306
R1314
1SS355WTE-17
0

C1316
C1317
C1318
C1319
C1320
C1321
C1322
C1323
C1324
C1325
C1326
C1327
C1328
C1329
C1330
C1331

100p
100p
100p
100p
100p
100p
100p
100p
100p
100p
100p
100p
100p
100p
100p
100p

C1307
0.1

R1313
270
D1313
SELU5420E-STP15

Q1309
DTC123JKA-T146
LED DRIVER

SUB WOOFER
ON/OFF

10
11
12
13
14
15
16
17
18
19
20
21

R1306 47

Q1300(2/2)
CPH5504
OSC

C1305
10
50V
22
23
24
25
26
27
28
29

D1314
1SS355WTE-17
C1311
10
16V
C1310
100p

CN1402
25P
JR1305 0

IC1300
NJU3427FA2
C1312
0.001

IC1300

R1307
4.7k

DISPLAY CONTROL

C1313 0.001
R1353
100
R1351 100
R1352 100

MAIN
BOARD(2/3)
CN201
(Page 37)

S1301
I/

33

34
35
36

C1314
0.001

R1361
4.7k

C1315
0.001

D1304
SELU5223C-STP15
I/

JW1322

R1308
1k

JW1300

R1345
100
Q1303
2SB1132-P
LED DRIVER

R1311
2.2k

Q1311
DTC143TKA
FL DRIVER

R1348
1k

SUB WOOFER
ON/OFF

R1324
330

Q1304
2SB1132-P
LED DRIVER

S1315

S1316

Q1312
DTC143TKA
FL DRIVER
R1323
470

S1314

R1332
680
S1320

Q1307
DTC123JKA-T146
LED DRIVER

Q1306
DTC123JKA-T146
LED DRIVER
S1324

40

44
R1319
2.2k

R1318
4.7k

S1310

S1309

R1330
330

R1331
470
S1322

S1323

ILLUMINATION/
SUB WOOFER LEVEL
R1328
1k

40

S1311

S1312

S1313

S1321

DIRECTION/
KARAOKE

HCD-GNX660

R1320
1.5k

R1321
1k

R1322
680

Q1315
DTC143TKA
FL DRIVER

DISC SKIP
EX-CHANGE

LED2
LED1

Q1305
DTC123JKA-T146
LED DRIVER

Q1314
DTC143TKA
FL DRIVER

Q1313
DTC143TKA
FL DRIVER

OPEN/CLOSE

VOL
BOARD
NO1402
(Page 42)

R1360
4.7k

R1359
4.7k

R1358
4.7k

R1357
4.7k

Q1310
DTC114EKA
LED CONTROL

Q1308
DTC114EKA
LED DRIVER

R1347
470

S1302
CN1452
11P

R1346
1k

45

47

48
R1356
4.7k

46

43
42
41
40
39
38
37

S1300

R1355
100

Q1316
DTC143TKA
FL DRIVER

S1327

R1327
680
S1326

R1326
470
S1325

R1325
330
S1317

R1317
10k

S1307

HCD-GNX660
Ver. 1.2
7-16. PRINTED WIRING BOARDS MIC, VOL and SPEAKER BOARDS

: Uses unleaded solder.

8

10

11

J1450
MIC 2

J1400
MIC 1

-13

See page 25 for Circuit Boards Location.

RV1400
MIC 1 LEVEL

RV1402
ECHO LEVEL

RV1401
MIC 2 LEVEL

R1418

C1405
JW1413
JW1415 R1425

D1400

C1429
R1427
R1426
JW1417
C1433
C1418
R1439
JW1400
R1431
C1434
R1437
JW1418
JW1419
JW1420
JW1421

PL1402

VOL BOARD

M
SPEAKER BOARD

S1318

JW1396
C1334

JW1431

D1310
(LED 6)
R1371
R1372
R1373

SMASTER
BOARD
NO680
(Page 45)

SMASTER
BOARD
NO580
(Page 45)

JW1399
JW1427

D1307
(LED 1)

JW1530

CN1600

JW1500

JW1510
JW1520
C1532

Semiconductor Location
JW1521

Ref. No.

C1502

S1328

C1512

C1612

C1522
EP1501

EP1500

C1602

R1365
R1366
R1367

LP1701

S1306
> OPERATION DIAL >

R1363

D1308
(LED 2)

R1336
R1337
R1334

S1305
MASTER
VOLUME

PL1700

JW1398

R1364
R1362

S1331
GROOVE

JW1610

R1333
R1335

JW1397

R1374
R1375
R1376

SMASTER
BOARD
CN503
(Page 45)

PL1500

JW1600

JR1301

PL1300

11 11
(12) (13)

CN1500

D1309
(LED 3)

EQ BAND/MEMORY

1-868-831-

JR1302

D1312
(LED 4)

D1311
(LED 5)

C1487

JR1300

R1368
R1369
R1370

S1319
MP3 BOOSTER

MAIN
BOARD
CN205
(Page 35)

JW1389

R1377

R1379

R1329

R1378

NO1402 11

Q1401

C1424
R1436
C1437
JW1439 C1436
C1486 JR1483
NO1404 R1435
JR1433
R1485
1
3
R1483 R1482

PL1400

R1443
R1442

R1486

JW1440
JW1423

PANEL
BOARD
CN1452
(Page 39)

Q1400

JR1403

R1422

EPT1400

EPT1403

R1433
R1432
R1434

NO1401

Q1450

Q1451

5
R1441

R1492

JW1424

C1468
R1476

C1479

-13

JW1438
JW1425

R1493
C1415

R1440

IC1401

R1477

JW1414

JW1410

R1406

R1484

JW1432

C1459

C1435

R1412
R1415
C1427

R1414
JR1427 C1419

C1430

R1405 JW1416

R1424

C1416

R1438
C1413
R1413

JW1409

C1438

C1460

C1406

30

16

C1412

IC1400

C1458

15

R1457

C1409

JW1429

C1401

C1410
JW1401

JW1402

EPT1402

C1461

C1403

JW1411

R1401

JW1404

R1407

R1411
R1410
C1411
R1409
JW1437

R1404

JW1407 JW1408

R1461
R1460
R1459

MIC BOARD

R1403

JW1405

C1408

JW1412
C1404

C1401

JR1417
JW1403

C1400

R1417
C1407 R1402

JW1430

C1432

-12

R1416

J1401
PHONES

11 11
1-869-011- (12) (13)

PRESET EQ

TM1500

+
1-868-832-

11 11
(12) (13)

SUB
WOOFER

HCD-GNX660

41

41

Location

D1307
D1308
D1309
D1310
D1311
D1312
D1400

G-3
F-4
E-3
G-2
F-2
E-2
B-6

IC1400
IC1401

C-4
C-5

Q1400
Q1401
Q1450
Q1451

C-8
C-8
C-8
C-8

FRONT SPEAKER

HCD-GNX660
Ver. 1.2
See page 53 for IC Block Diagrams.

7-17. SCHEMATIC DIAGRAM MIC, VOL and SPEAKER BOARDS

R1417
5.6k

R1418
1k
C1407
47
16V

C1406
47
16V
C1409
1
50V

R1461
10k

R1403
100

JR1417
0

S1331

RV1401
50k
MIC 2
LEVEL

R1401
4.7k

R1402
100

R1336
4.7k

S1328

R1335
2.2k

R1334
1.5k
PL1300

C1408
4.7
50V

R1337
10k

D1400
UDZSTE-175.1B

S1318
S1305

C1403
68p

R1404
100

IC1400
TC9488FG

JR1302
0

D1307
SELU5223C-STP15

IC1400

C1461
0.01

PANEL
BOARD
CN1452
(Page 40)

MASTER
VOLUME

R1459
10k

R1363 1k

DIGITAL ECHO

R1366 1k
C1458
4.7
50V

C1411
0.01

J1400
R1411
10k

R1413
6.8k C1427
1
0.5%

R1457
1.5k

-13

C1438
0.1

C1459
1
50V

R1414
12k

R1415
15k

R1369 1k

R1406
330

R1412
3.9k

C1460
1
50V

R1410
1k

D1309
SELU5223C-STP15

C1413
0.0012

D1310
SELU5223C-STP15
R1372 1k

R1405
330
D1311
SELU5223C-STP15

C1419
0.0047

R1375 1k

R1438
0

D1312
SELU5223C-STP15

JR1427
0

R1362 1k
R1364 1k

D1308
SELU5223C-STP15

R1409
10k

NO1402
11P

R1333
1k

C1334
0.1

JR1301
0

J1450

R1329
1.5k

C1404
47
35V

C1405
0.01

C1412
0.1

C1400
0.1

S1319

S1306

R1407
1.5k

C1410
1
50V

R1460
1k

RV1402
50k
ECHO
LEVEL

R1416
5.6k

RV1400
50k
MIC 1
LEVEL

R1378 1k

R1365 1k
R1367 1k
R1368 1k
R1370 1k
R1371 1k
R1373 1k
R1374 1k
R1376 1k
R1377 1k
R1379 1k

C1416
22
50V

R1431
0

IC1401(1/2)
NJM4565M-D

IC1401
MIC AMP

R1424
10K

IC1401(2/2)
NJM4565M-D

R1439
2.2k

R1425
10k
R1426 C1418
56k
390p

R1427
22k

C1468
0.001

C1430
0.1
50V

C1401
0.1

C1415
0.1

R1477
15k

C1429
0.1
50V

C1435
220
10V

R1476
22k

R1422
0

C1434
10
50V

R1434
10

C1437
0.01
R1436
4.7k

Q1401
2SC3661
MUTING

C1487
0.01

R1442
1k

R1484 10
JR1483
0

R1485 10

C1502
1000p

JW1500
JW1510

JW1520

C1512 1000p

JW1530

C1522 1000p

FRONT SPEAKER
L

C1532
1000p

NO1404
3P
EP1500
SMASTER
BOARD(1/2)
CN503
(Page 47)

R1493
1k

R1492
1k
Q1451
2SC3661
MUTING

SUB
WOOFER

R1443
1k
JR1401
0

R1486
4.7k

EPT1403

SMASTER
BOARD(2/2)
NO580
(Page 48)

R1432
10

Q1450
2SC3661
MUTING

R1482
10

R1483
10

C1486
0.0047

HCD-GNX660

42

42

TM1500

C1612
1000p

SMASTER
BOARD(2/2)
NO680
(Page 48)

R1433
10
Q1400
2SC3661
MUTING

C1602
1000p

JW1600
JW1610

C1436
0.0047

J1401

C1424
0.1

CN1600
2P

CN1500
4P
R1435 10

EPT1402

MAIN
BOARD(1/3)
CN205
(Page 36)

R1437
100k
C1433
47p

R1440
2.7k

C1432
0.1
-13

C1479
4.7
50V

JR1433
0

EPT1400

NO1401
5P

R1441
0

JW1400

EP1501

HCD-GNX660
Ver. 1.1
7-18. PRINTED WIRING BOARD ADC BOARD

See page 25 for Circuit Boards Location.

: Uses unleaded solder.

H
ADC BOARD (SIDE A)

SMASTER
BOARD
CN501
(Page 45)

EP02

C32

C81

C61

C62

LP01

R57

C93 R59
C70

C65
C66
C63

C41

R58

JR21

D52

C60

C22

C59

C56

C67

C64

C27

C24

C58
D51

C55

R67
R64
C51

C57

C50

D12
C40 D11
C42

10

D61

C53

C90

C25

D14

NO05

D13

C91

EP01

CN01

C20

ADC BOARD (SIDE B)

1-868-834- 11
(11)

MAIN
BOARD
CN381
(Page 35)

C
L0 1

1
R25

IC03

C54

JR51

R36

R55

R60

C68

C28
C29

R50

R40

C26
R38

R63

R29

R65

R52

R31

R53

L02

3 FL01

X001

L03

R41

1
C23

R27

IC02

IC01

FL02

IC12

IC11
JR52

1-868-834- 11
(11)

HCD-GNX660

43

43

Semiconductor
Location
Ref. No.

Location

D11
D12
D13
D14
D51
D52
D61

A-2
A-2
A-1
A-1
B-3
B-2
B-4

IC01
IC02
IC03
IC11
IC12

C-2
D-1
D-2
D-2
D-4

HCD-GNX660
Ver. 1.1
7-19. SCHEMATIC DIAGRAM ADC BOARD

See page 55 for IC Block Diagrams.

JR21
0
R63
100

C70
1
50V

CN01
17P

D61
C93
1SS355TE-17
1000p
C63 10 50V
C64 0.1
C65 10 50V
C67
100
C66 0.1
10V

C41
0.1

R25
2.2k

C81
0.01
C68
0.1

C32
0.01

EP02

R65
0

R27
100k
MAIN
BOARD(1/3)
CN381
(Page 36)

IC12
PCM1803DBR

R29
2.2k

IC12
A/D CONVERTER

R31
100k

NO05
10P
R57
0
R58
0
R59
0

IC01
uPC2905T-E1

IC01

FL02
0uH

+5V REG
C20
0.1
50V

R60
0
L03
10uH

C62
10
50V

R67
0

C61
0.1

C22
100
10V

C60 1 50V

IC02
uPC2933T-E2

IC02
L01
1uH

C59
1
50V

+3.3V REG

D14
1SS355TE-17

C25
0.01

R38
0

D13
1SS355TE-17

R40
1k
R41
1M

EP1

C55
C56
C57
C58

C90
0.001

C28
10p

X001
12.288MHz

IC03
TC7WU04F
(TE12R)

D51
1SS355TE-17

R52
100

C91
0.001

C24
100
10V

C23
0.1

C40
0.1

D52
1SS355TE-17

R53
100

C29
10p

10 50V
0.1
10 50V
0.1

C54
0.1

C53
100
10V

R55
0

IC11
PCM1803DBR

IC11
A/D CONVERTER

IC03
CLOCK GENERATOR

C51
10
50V

R36
0
JR52
56

C26
0.1

JR51
56

C27
4.7
50V
L02
FL01
0uH 10uH

HCD-GNX660

44

44

C50
0.1

R50
0

R64
0

C42
0.1

D11
1SS355TE-17
D12
1SS355TE-17

SMASTER
BOARD(1/2)
CN501
(Page 47)

HCD-GNX660
Ver. 1.2
7-20. PRINTED WIRING BOARD SMASTER BOARD (SIDE A)
2
1

See page 25 for Circuit Boards Location.

: Uses unleaded solder.

SPEAKER
BOARD
CN1500
(Page 41)

L
SMASTER BOARD (SIDE A)

SPEAKER
BOARD
CN1600
(Page 41)

C580

L590

C584

R841

R840

R691

C691
C693

R865 R860
R866 R861
R867 R862

EP884

E
Q840

C692

C668

NO502 -13, -21

CN502 -12

C548

C587

C830

C669

C592

C590

L591

R583

C586

K
POWER
BOARD
CN1101
(Page 51)

C690

C694

L691

C569

C594

R855 R852

C585

L581

R820

C568

R868

R859

C549

C876

C593
D820 R822

R823
R821

C591

D890

-12

NO680

R851

L580

D891

-13, -21

R591

EP885

EP885

R856

L690

NO580

C840

R858 R857 R850

Semiconductor
Location
Ref. No.

D895

C879

D896

C558

C538

C565

D553

C545

D533

D554

D653

D534

C886

C665

C658

D654

EP886

EP886

R662

C531

C655

R668

C667

EP882

C651 R650

C611

IC810

C609

1
R612

C805

10

CN501

R811

C606

CN500

C612

L802

C610
C607

C509

R512

C604

C511

C507
C510

C608

R602

1
EP880

R510
R886
C883
FB881

-12

CN503

MIC
BOARD
NO1404
(Page 41)

E-8

Q840

B-6

MAIN
BOARD
CN105
(Page 35)

HCD-GNX660

45

45

ADC
BOARD
NO05
(Page 43)

11
(12)
11
(13)

EP880

11
(21)

1-868-959-

IC810

C810

R502

R892

D-2
D-3
D-1
D-2
D-4
D-4
B-1
E-8
E-8
E-1
E-1
B-1
B-1
D-1
D-1

5 4 C811

D881

R530

R669

R667

R548

R549

R547

C656

C653
R884

C881

C889 C892

C547

C533

C512

C887

C891

R894

C888

R895

-13, -21

C535

C504

C802

D883
D882
C872

L801
C506

EP881

R542

C508

C804

C800
EP881

R550

C551

C803

C536

C553

C890

C890

C567

C871
D880

C555

R562

R568

C556

R569

R567

Location

D533
D534
D553
D554
D653
D654
D820
D880
D881
D882
D883
D890
D891
D895
D896

-12

-13, -21

HCD-GNX660
Ver. 1.2
7-21. PRINTED WIRING BOARD SMASTER BOARD (SIDE B)
2
1

See page 25 for Circuit Boards Location.

: Uses unleaded solder.

C597

C581

C595

LP800

R593

C596

R581
C583
C582

Q856
C855

Q850

Q866

Q865

Q851

C695

E
E

E
E

Q855

LP801

D889
D888

-13, -21

E
E

C877

C850

C865

C697
C696
R693

SMASTER BOARD (SIDE B)

-12

B
Semiconductor
Location
Ref. No.
D535
D536
D555
D556
D655
D656
D884
D885
D888
D889
D892
D893

-13, -21

46

46

R553 R552

D555
R893

R888

R887

IC880

C884
R883

E-7
D-6
D-7
E-5
D-5
E-7
E-3
E-8

Q850
Q851
Q855
Q856
Q865
Q866

A-6
A-6
A-6
A-6
A-6
A-5

11
(12)
R891 R889

C880

R885

R880

C505

R503
R505
R506
R507

R516
R517
R519
R520
R521
R500
R501

IC500

IC500
IC530
IC550
IC600
IC650
IC800
IC802
IC880

X800

R890

R523

R524

R526

C521

C513

R529

R533

C878

D892

D893

FL800
R511
R509 R881

C882

HCD-GNX660

C557

C520

C523

R559

IC550

R882

-12

C576

R557

D556

D535

C564

C537

C524

IC530

C577

C522
C532
R551 C552
C534
R531
C554
C527
C526
R558
R541 C525
R561
C529
R535
FB801 R555
R802 R801
R515
R800
FB800
4 3
L800 5 1
C801 IC800

R532

R661

R655

C528

R652
R609
R610
C605

C578

C620

C544

R657

R653

C623

R624

R623

C626

C575 C574

C579
C621 R560

IC600

R603
R605
R606
R607

R619
R620
R621
R600
R601

C613

C809
R809

R615

R617

R616

R807

R806
R805
R804

FL810

1
3

FL801

C806

IC802

C657

C652
R651
C654

C629

D885
D884

C873

C622
R658

IC650

D536

C677 C676
C664

D655

D656

11
(13)

11
1-868-959- (21)
C885

Location
C-7
C-6
C-8
C-7
C-5
C-4
D-1
D-1
A-1
A-1
E-5
E-5

HCD-GNX660
Ver. 1.2
7-22. SCHEMATIC DIAGRAM SMASTER BOARD (1/2)

See page 55 for IC Block Diagrams.

BUS1

DATA_2

R805 0
R806 0
R807 0

LRCK_1
BCK_1
DATA_1

ADC
BOARD
NO05
(Page 44)

SCDT
SCSHIFT
SCLATCH_2

R612
10k

R619 1k
R620 1k
R621 1k

SCDT
SCSHIFT
SCLATCH_2

C612
0.1

-12

C613
0.1

OVF(SW)

R615
56

R600
0

-13
-21
IC802
MC74VHC1GU04DFT1

OVF

IC802
R809
56

C809
0.1

XFSIIN

R602
10k

R603
100

EP880

LRCK_1
BCK_1
DATA_2

IC600
CXD9843AR

R605 470
R606 470
R607 470

LRCK_2
BCK_2
DATA_2

R624
0

IC600

R609
0

C604
0.1

MAIN
BOARD(2/3)
CN105
(Page 37)

C611
0.1

XFSIIN
L802
0

SCDT
SCSHIFT
SCLATCH_1

STREAM
PROCESSOR
C605
0.1

OVF(SW)

EP884

EP882

INIT

CN500
19P

SCLATCH_2
FAN DET
DBFB F/B

-13
-21

-13
-21

R601
0

OVF

INIT
FL801
0uH

INVERTER

C877 0
D888 0
D889 0

R804 0

NSPMUTE
SOFTMUTE

C873 0
D884 0
D885 0

CN501
10P

R616 100
R617 100

C871 0
D880 0
D881 0

NSPMUTE
SOFTMUTE

R623
0

C610
0.1
C609
100
10V

R610
0

C878 0.1
D892 1SS355TE

OVF
/RST
/SD
/OTW
NSPMUTE
SOFTMUTE

D893 1SS355TE

NSPMUTE
SOFTMUTE
SCDT
SCSHIFT
SCLATCH_1

INIT

C606
0.1

R516
R517
R519
R520
R521

NSPMUTE
SOFTMUTE
SCDT
SCSHIFT
SCLATCH_1

100
100
1k
1k
1k

C607
0.1

C608
0.1

R512
10k

SMASTER
BOARD
(2/2)
(Page48)

R515
56

C810
100
10V

C513
0.1
C512
0.1

IC810
NJM2870F18

OVF

IC810

OVF

C811
0.01

R500
0

R502
10k

+1.8V REG

R501
0

C504
0.1
R811
100k

INIT
C805
100
10V

D882
0

EP881

D883
0

C883
470
10V

C882
100p

C889 C888
100
0.1
16V

IC500
CXD9843AR

R524
0

IC500

R523
0

STREAM
PROCESSOR

R885
33k

XFSIIN
R880
22k

R882
22k
R883
22k

C511
0.1

R509
0

C509
100
10V

C880
100p
R881
22k

R886
0

C881
100p

R884
22k
R895
22k

IC880

C890
100
16V

HP AMP
FB881
0

C892
100p

R892
0
C887
470
10V

R887
22k

C885
100p

R890
22k

C884
100p

R511
0

IC800
MC74VHC1GU04DFT1

IC800

C510
0.1
C508
0.1

C507
0.1

C506
0.1

C803
0.001

OSC

C800
22
25V

R800
1M
C801
0.01

R801
100

C804
10p

L801
1uH

X800
49.152MHz

C802
5p
7

C891
0.1

R894
2.2k

R889
22k

R891
33k

R510
0

R893
2.7k

IC880
NJM4580V

MIC
BOARD
NO1404
(Page 42)

R505 470
R506 470
R507 470

LRCK_1
BCK_1
DATA_1

R526
0

C505
0.1

-13
-21

CN503
3P

LRCK_1
BCK_1
DATA_1

INIT

C806
0.01

-12
C872
0

FL810
0uH

R529
0

R503
100

FB800
0

L800
0

FL800
0uH

DBFB F/B

FB801
0

R802
56

R888
22k

HCD-GNX660

47

47

HCD-GNX660
Ver. 1.2
7-23. SCHEMATIC DIAGRAM SMASTER BOARD (2/2)

NC680
2P

FAN DET
C830
10
50V

R857
100k

C855 R856
10 100k

Q856
2SA1602
DC DETECT

R868
47k

R855
100k

C865
10

NO580
4P

Q855
2SA1602
DC DETECT

R867
100k
R866
100k

C692
0.0022

R865
100k

R691 R693
2.7
2.7

C693
0.0022

R852
100k

C697
0.0022

C850
10

R851
100k

C696
0.0022

C691
0.22
C690
1

C582
0.0022

R850
100k

C695
0.22

C586
0.0022

C581
0.22

C585
0.22

C580
1

C584
1

C593
0.0022

-12

Q851
2SA1602
DC DETECT

Q866
2SA1602
DC DETECT

C592
0.0022

R581 R583 C587

2.7 0.0022
2.7

C583
0.0022

Q850
2SA1602
DC DETECT

C694
1

D891 0
D890 0

R591 R593
2.7
2.7

SPEAKER
BOARD
CN1500
(Page 42)

C596
0.0022

C597
0.0022

C591
0.22

C595
0.22

C590
1
63V

C594
1
63V

R822
22k

L581
10uH

L580
10uH

L590
10uH

C876
0

L591
10uH

R840
100k

C677
1

IC650
CXD9879M

R667
1.5

C656
0.033

C657
0.1

C579
0.001

C547
0.033

R560
4.7

C544
0.1

R548
1.5

R547
1.5

R559
4.7

C524
0.001

C525
0.001
C537
0.1

IC530
CXD9879M

C577
1

C522
0.001
R558
4.7

C523
0.001
C567
0.033

C536
0.033
IC550
CXD9879M

IC650

IC530

IC550

POWER DRIVER

POWER DRIVER

POWER DRIVER

R568
1.5

D553
P6SMB62AT3

C574
1

D554
P6SMB62AT3

C565
120
63V

POWER
BOARD
CN1101
(Page 52)

C558
120
63V
C576
1
C557
0.1
R557 C521
4.7 0.001

C564
0.1

C520
0.001

R820
22k

C556
0.033

R567
1.5

/SD
Q840
2SC1623
PROTECT DETECT
-12

EP886

C528
0.01

C629
0.01

C529
0.01

R549
3.3

C555
0.1

C552
0.1
C526
470p

R561 10

R555 33k

R550
10 -12
C551
0 -13, -21 0.1

R551 100
R552 100
R553 100

C527
470p

R542
10 -12
0 -13, -21

R530
10 -12
C531
0 -13, -21 0.1

C532
0.1

C553
22
25V

C535
0.1

R541 10

100
100
100

C655
0.1
R662
10 -12
0 -13, -21

C554
0.1

C533
22
25V
R535 33k

R669
3.3

C534
0.1

R531
R532
R533

C651
0.1

R661 10

R650
-12 10
-13, -21 0

C654
0.1
C653
22
C652 25V
0.1
C626
470p

R655 33k

-13, -21

R651 100
R652 100
R653 100

C879 0
D895 0
D896 0

R562
10 -12
0 -13, -21

R569
3.3

HCD-GNX660

48

48

8
9

BUS1

/OTW
/SD
/RST

SMASTER
BOARD
(1/2)
(Page 47)

CN502 -12
6P
NO502
-13, -21
6P

C886
470
16V

C569
2200
63V

D555
EC10UA20

C578
0.001

C538
120
63V

D556
EC10UA20

C621
0.001

R668
1.5

C664
0.1

C620
0.001

D533
P6SMB62AT3

R657
4.7

C545
120
63V
C575
1

D535
EC10UA20

C667
0.033

R658
4.7

C658
120
63V
C676
1

D655
EC10UA20

-12

C622
0.001

D656
EC10UA20

C840
2.2
16V

C623
0.001

D654
P6SMB62AT3

C665
120
63V

C568
0.1
100V

C549
2200
63V

C548
0.1

D536
EC10UA20
D534
P6SMB62AT3

R841
0

C669
2200
63V

D653
P6SMB62AT3

C668
0.1

R821
1.5k

D820
1SS355TE-17

-13, -21

-13, -21
C840
220
16V

R823
22k

EP885
L691
10uH

L690
10uH

Q865
2SA1602
DC DETECT

SPEAKER
BOARD
CN1600
(Page 42)

R859
47k

R858
47k

HCD-GNX660
7-24. PRINTED WIRING BOARD CDG BOARD

See page 25 for Circuit Boards Location.

: Uses unleaded solder.

MAIN
BOARD
CN321
(Page 35)

IC1005

R1030

R1015

R1020

Q1001

C1022 R1029

C1015

C1006

E
Q1005

Q1004

R1017

C1013

C1003

R1016

3
Q1010

C1005
JW1009

C1004

R1003

C1018

X1002

R1018
JW1008

46

45

R1013

C1023

R1011

C1024

JW1014

C1025

C1030

IC1006
C1026

FB1001

C1007

R1005

R1031

R1006

JW1019

J1001

60

C1039

Q1009

JW1007

C1010

R1022 R1021 R1004

C1019

IC1001

31

JW1015

JW1020

C1028

JW1013

30

JW1003

JW1010

JW1011

JW1012

L1001

JW1018

C1027

C1001

C1002

R1012

IC1003

15

16

JW1017

VIDEO OUT

C1036

L1002

C1029

13

R1023

JW1004
JW1016

C1037

C1011

CN1001

JW1002

IC1002

N
Q1008

C1012

C1038

C1021

JW1006

14

D1003

E
2 CN1003

18

JW1005

22

C1008

MAIN
BOARD
NO560
(Page 35)

26

C1014

R1033

R1034
R1032

EP1001

Q1007

D1004

CDG BOARD

Q1006

Q1002

R1019

E
Semiconductor
Location
Ref. No.

1-864-878-

HCD-GNX660

49

49

11
(11)

Location

D1003
D1004

B-5
A-5

IC1001
IC1002
IC1003
IC1005
IC1006

C-5
B-3
C-2
B-6
D-3

Q1001
Q1002
Q1004
Q1005
Q1006
Q1007
Q1008
Q1009
Q1010

D-5
D-5
D-6
C-7
D-5
A-3
B-2
C-6
D-3

HCD-GNX660
7-25. SCHEMATIC DIAGRAM CDG BOARD

CN1001
13P

See page 25 for Waveforms.

See page 53 for IC Block Diagrams.

R1023
220

SCOR
WFCK

SCOR
WFCK

C1037
220p

C1036
220p

EXCK
MUTE_DATA
_HALT-CLK

IC1005
SN74AHCT04NSR

_CDG-RST

MAIN
BOARD
(1/3)
CN321
(Page 36)

CDG/_BGC
CDG-DET

C1038
220p

CDG-POWER

BUFFER

IC1002
MSM514400E-60TS-K

VMUTE
R1022
220

Q1005
DTC114EKA-T146
BUFFER

R1021
220

EXCK

Q1009
DTA114EKA-T146
BUFFER

DRAM

C1001
0.01

C1039
220p

L1002
0

C1011
0.01

R1003
4.7k

MUTE_DATA
R1020
10k

R1004
2.2k

Q1004
DTC114EKA-T146
BUFFER

C1019
22p

C1014
0.01
C1012
47
35V

R1015
0

_HALT-CLK
R1019
10k

Q1006
DTA114EKA-T146
BUFFER

R1017
10k

C1018
22p

X1002
14.31818MHz

R1018
10k

IC1001
TC9411AFG

C1015
0.01
Q1002
DTC114EKA-T146
BUFFER

VIDEO D/A
C1003
0.01

_CDG-RST

R1016
10k

C1005
0.01

R1029
100

D1004
1SS355TE-17

Q1001
DTC114EKA-T146
BUFFER
C1022
22p
C1021
0.001

R1005
2.2k
R1006
4.7k

CN1003
2P
C1008
1 50V

R1012 4.7k

CDG-DET
Q1010
DTC114EKA-T146
BUFFER

C1004
0.01

C1023
1
50V

R1032
10k

+5V REG

L1001
0

Q1007
DTC114EKA-T146
+B SWITCH

R1033
4.7k

IC1003
TA7805LS

C1007
0.01
R1013
820

VMUTE

R1034
4.7k

C1002
0.01
R1011 2.2k

CDG/_BGC

D1003
1SS355TE-17

C1028
100
10V

C1006
0.01

C1013
100
10V

C1025
0.01

C1024
100
10V

N
Q1008
2SB1116A-L
+B SWITCH

C1010
100
10V

MAIN
BOARD
(1/3)
NO560
(Page 36)

EP1001

C1029
0.47
C1027
220p

IC1006
NJM2575F1-TE2

R1030
22k
FB1001
0

VIDEO BUFFER

C1030
22
50V

C1026
470
6.3V

R1031
75

CDG-POWER

HCD-GNX660

50

50

J1001

HCD-GNX660
Ver. 1.2
7-26. PRINTED WIRING BOARD POWER BOARD
2

See page 25 for Circuit Boards Location.

3

: Uses unleaded solder.

11

10

POWER BOARD
-12

EP1105

-13

C1149

C1149

JW1139

JR1101
JW1185

EP1104

R1232

R1144

Q1101

R1225

R1226 S
JW1132

JW1131

S
Q1206

C1137

CN1101

C1221

E
R1231

1-868-958-

HCD-GNX660

51

51

SMASTER
BOARD
CN502
(Page 45)

JW1120

CN1200

PC1102

C1139

EP1106

R1223

EP1200

JW1135

JW1134

R1230
C1217

JW1146

IC1201

R1131

C1219

R1217

E
Q1203

R1227

JW1142

R1218
C1212
E
K
C
A

R1220

R1130
E
R1229
Q1205 Q1204

R1224

JW1122
JW1121

C1136

R1129

JW1130

JW1143

C1214

A
K

L1201
C1216

R1219

R1215

C
E

R1216

R1221

D1202

PC1200

JW1155

R1214

D1212
JW1144

R1128 D1115

D1215

D1213

C1135

C1218

L1200

R1132
C1129
R1133

JW1137

C1213

R1114
R1115

R1116

R1141

R1152
C1150

D1110

R1142

JW1184
JW1124

C1138

C1222

IC1200

JW1173

JW1133

JR1108

JW1106

JW1104

JR1103

R1139

D1211

JW1156

JW1125

JW1127

L1100

Q1100

D1206

D1122
D1112 D1111

JW1176

D1116

L1102

R1118
JW1141
JW1140

R1135

JW1129

C1116
C1130

C1148

JW1145

JR1107

R1140
R1126
R1145

JW1148

EP1103

JW1147

D1203

JW1128

JW1136 R1228

C1206

T1200
SUB POWER
TRANSFORMER

C1209
R1203

R1138

R1120

VD1100

C1203

FH1101

F1100

D1200

C1200

D1208
R1208
R1207

D1108

Semiconductor
Location

JW1126

JW1150

R1147 R1110
JR1150

JW1149

C1126

C111

R1112
C1122
R1111

C1134

C1125

C1121

C1120

JW1123
R1201

D1204

R1211
C1208
C1207
R1209
JW1159 R1210

R1137

D1214

R1200

JW1157

JW1161

JW1158

10

AC IN

R1113

C1202

JW1111

JW1112

JW1110

JW1109

EP1100

JW1162

C1210

D1118

JW1164

FH1100

C1140

T1100
MAIN
POWER
TRANSFORMER

D1205

R1212

CNP1100

C1127
C1124

JW1138

Q1200
E

R1202
D1207

C1101

JR1106
R1123

C1112
JW1160

JW1166
JW1165

R1234
R1233

C1109
JW1178

JW1163

C1123

R1124

JW1101

D1101

0
C1

R1122

JR1105

D1119
C1107

LF1101

R1136

C1118

JW1152

JW1170
JW1169

JW1149

IC1102

D1114

IC1101

R1117
A
C
D1120
K
E
PC1101 R1146
R1121

TH1100

JW1168
JW1167

A
K

D1113

R1103

D1100

R1

R1110
D1108

C
E

Q1102
R1143

C1147

D1117

11

C1120

R1108

D1102

JW1172

JW1171

JW1150

R1109
C1117

D1110

C1119
D1106

D1109 C1122
R1115 R1114

R1111 D1111

D1112

R1106

EP1102

JW1154

R1141
R1116 PC1100

R1112

JW1179

D1122

JW1151

C1113

7
A

JW1176

IC1100

D1103
R1105

D1107

Q1102

R1142

EP1101

C1131
R1127

D1109

MAIN
BOARD
CN590
(Page 35)

11
11
(12) (13)

Ref. No.
D1100
D1101
D1102
D1103
D1106
D1107
D1108
D1109
D1110
D1111
D1112
D1113
D1114
D1115
D1116
D1117
D1118
D1119
D1120
D1122
D1200
D1202
D1203
D1204
D1205
D1206
D1207
D1208
D1211
D1212
D1213
D1214
D1215

Location
C-2
C-3
C-2
A-4
B-4
A-5
B-6
B-6
B-6
B-6
B-6
A-7
A-8
E-8
B-9
C-9
E-4
D-5
B-7
A-6
E-5
F-5
F-4
D-4
D-4
E-5
E-4
E-4
F-4
F-6
F-7
D-5
F-8

IC1100
IC1101
IC1102
IC1200
IC1201

A-5
B-7
A-9
E-4
G-6

Q1100
Q1101
Q1102
Q1200
Q1203
Q1204
Q1205
Q1206

E-8
E-8
A-5
D-4
F-8
F-8
E-8
G-8

HCD-GNX660
Ver. 1.2
7-27. SCHEMATIC DIAGRAM POWER BOARD

C1109
330p
125V
JW1112
JW1111

LF1101
C1107
0.22
275V

VD1100

AC IN
R1120
3.3M
CNP1100 1/2W
2P

EP1102

TH1100
D1100
D5SBA60F01

C1115
220p
125V JW1185
C1112
680
220V

JW1109

C1113
680
220V

JW1110

D1101
R1103
R4KLB-LF015-303
0.1
1W
D1102
R4KLB-LF015-303

R1106
100k
3W

POWER SWITCHING CONVERTER

D1106
EG01CV1

R1109
0.05
5W

R1108
0.33
1W

R1111 R1112
47k
27k

D1107
MTZJ-T-72-22D
C1119
0.1

-13

R1147
5.6k

JW1101

C1123
0.01
D1113 630V
FCH20A20

R1105
100k
3W

C1126
1200
63V

C1121
220
35V

R1114
22k
C1122
0.0033

D1122
HRU0103ATRF

D1109
MTZJ-T-72-22D

C1130
0.0022

C1127
1200
35V

C1131
470p

D1120
UDZSTE-17
5.1B

JR1103
0

R1124
56k
0.5%

R1129
6.8k
0.5%

R1126 R1127
47k
0

D1122
HRU0103ATRF

R1142
470k

EP1103

R1117
3.3k
0.5%

R1132
10k

C1134
820
25V

D1116
RK36LF-B3

R1131
10k

D1117
MTZJ-72-22D-T

R1136
0

L1102
100uH

C1140
0.1

R1144
10k

R1139
10k

R1128
1.8k
0.5%

VOLTAGE DET

C1148
0.0027

D1115
UDZSTE-17
Q1100
5.1B
2SC2713
MAIN ON/OFF
SWITCHI

C1129
0.1

C1219
0.1

R1133
10k

C1218
0.1
D1215
MTZJ-T-72-22D

PC1101
TLP421F(D4-GR)

C1212
330p
125V

Q1102
2SC2713
SWITCH

PC1102
TLP421F(D4-GR)

R1223
10k

D1202
D1NL20U-TR

R1152

R1201
2.2
1/2W

47k

C1150 R1141
470p 10k

PRIMARY SWITCHING,
MAIN CONVERTER

R1202
33k

C1203
0.1

R1233
10k

C1200
3300p
500V

D1204
D1NL20U-TR

C1206
47p

D1206
MTZJ-T-72-22D

D1207
D1NL20U-TR2

R1210
15k
Q1200
2SC2713
SWITCH

R1209
2.2k
R1234
47k

D1208
UDZSTE-1711B

D1213
RK36LF-B3

R1212
10k
R1211
1k

C1210
22
50V

R1217
47k

T1200
SUB POWER
TRANSFORMER

C1213
470
10V

IC1201
TA76L431S

R1216
220

VOLTAGE DET

PC1200
TLP421F(D4-GR)

HCD-GNX660

52

52

R1231
330
1W

R1227
100k
R1228
330

R1225
100

R1219
2.2k
0.5%

EP1200

R1215
1k

C1207
1000p

Q1203
RSR25P03
+4V REG

R1226
1M

R1220
220
0.5%

R1221
3.9k
0.5%

C1208
0.0068

D1205
MTZJ-T-72-22D

C1214
0.1

R1218
6.8k
0.5%

C1216
2200
16V

D1211
R1214
1 D1NL20U-TR2

C1209
100
25V

L1200
10uH

JW1173

JR1108
0
R1208
12k

R1207
4.7k

L1201

D1212
SF5S6

D1200
ERA22-08KF

C1202
100p
2kV

D1203
MTZJ-T-72-22D

R1200
100k
2W

Q1206
RSR25P03
+8V REG

C1222
10
50V

R1224
68k

Q1204
2SC2713
+4V REG

Q1205
2SC2713
+8V REG

R1229
10k
R1232
10k

CN1200
7P

C1221
470
16V

C1217 0.1

R1230
1k

R1203
10

C1149 R1143
10 35V 3.3k
IC1200
MR1722

C1138 C1139
0.1
470
16V

R1138
470k

R1137
470k

-13

SMASTER
BOARD(2/2)
CN502
(Page 48)
R1135
0

C1149 R1142 R1141

33 25v 47K 6.8k

D1118
10EDB60-TA2B5

CN1101
6P

+12V REG

Q1101
2SC2713
MAIN ON/OFF
SWITCHI

R1115
4.7k

C1135 C1136 C1137

0.1
470
470
63V
100V
63V

IC1102
SI-8120JF

IC1101
TA76L431S

R1140
1k

R1116
0

R1130
6.8k
0.5%

C1147
22
63V

R1146
6.8k
0.5%

JR1105
0

-12
Q1102
2SC2713
SWITCH

R1121
6.8k
0.5%

C1116
10

D1112
D1NL20U-TR2

R1122
2.2k
0.5%

R1123
3.9k
0.5%

JW1184

R1145
100

R1113
D1119
4.7 D1NL20U-TR2

PC1100
TLP421F(D4-GR)

C1120
68p

D1114
SF20NC15M

C1124 C1125
0.1
1200
63V
100V

D1111
UDZSTE-1716B

R1110
-12 15k
-13 10k

D1110
D1NL20U-TR2

JR1150

D1214
MTZJ-4.7C

D1108
MTZJ-T-72-22D

L1100
10uH
JR1101
0

D1103
SARS03
(TO-220)

JW1179

JW1106

R1118
1
2W

T1100
C1117 MAIN POWER
TRANSFORMER
0.0033
400V

IC1100
MR5060

C1118
820p

JW1104

JR1107

C1101
0.22
275V

F1100
T6.3AL/250V

JW1178

C1110
330p
125V

MAIN
BOARD(1/3)
CN590
(Page 36)

HCD-GNX660
IC Block Diagrams
DRIVER Board

CDG Board

IC701, 712 BA6956AN

IC1006 NJM2575F1-TE2

TSD

PWR 1

VCC

SAVE 2

GND

CONTROL LOGIC

75
DRIVER

VREF

OUT2

RNF

OUT1

VM

VCC

FIN

GND

RIN

VOUT 3

6dB

4 VIN

LPF
CLAMP

MIC Board

VSS

POOUT

TEST

NC

VOLST

DA OUT

NC

ADIN

PRIN

MCO

VSA

NC

ALC1

MC2N

MC2P

IC1400 TC9488FG

30

29

28

27

26

25

24

23

22

21

20

19

18

17

16

VREF

ALC
VREF
VREF

DAC

S/H

POST
LPF

ADPCM
DECODE

DELAY
DRAM

ADPCM
ENCODE

ADC

VREF

VREF

13

ALC1

14

15

MC1P

12

MC1N

11

NC

10

VDA

VREF

VRO

NC

VOL1 (CS)

OSCC

ALC

VOL3 (SDA)

NC

OSCR

VDD

VOLUME CONTROL

VOL2 (SCL)

OSC

BD84 Board

50k

Pre
Vcc

100k

PIN3

CH3OUTR

CH3OUTF

CH4OUTF

CH4OUTR

22

POWVCC

23

MUTE

24

GND

25
10k

GND

CH3RIN

26

CH3FIN

OUTVREF

27

CH4IN

DPOUT

28

CH4CAPA

PREVCC

IC251 BA5947FM-E2

21

20

19

18

17

16

15

50k

INTER
FACE

POW

VCC
50k (ch3,
4)

MUTE

Vref

50k

50k

50k

50k

LEVEL
SHIFT
6.5k
Vref PIN26

OPIN-

OPIN+

SW

CH1FIN

CH1RIN

CH2FIN

CH2RIN

10

11

12

13

14
CH1OUTF

CH1OUTR

CH2OUTF

POW
VCC
(ch1, 2)

CH2OUTR

POWVCC

INTER
FACE
R
F

CNF4

SW

POW
VCC

GND

GND

INTER
FACE

19k

10k
POW
VCC

53

54

49

50

51

52

53

54

55

56

57

58

59

60

61

62

63

64

AD3/PO03

AD2/PO02

AD1/PO01

AD0/PO00

VSS

VDD

CKO/PO13/AD16

VDDX

XO

XI

VSSX

TEST

MIMD

VSSP

VCOI

PO07/AD7 46
AD9 44
Bus
Switch

PO05/AD5 48

VC0

AD10 43
MCU. I/F

round & limit

A1
A3

round & limit

A2

ALU

AY

Audio I/F

Sub code
I/F

DIT

PIO1/SDI3/IO1
PIO0/SDI2/IO0
VSS
CKI/CLOCK/IRQ/FIO

VDD
TXO
SFSY/LRCKIB
SBSY/BCKIB
SDI1/DATA

PIO2/IO2

PIO3/IO3

26

A0

AX

1Mbit
SRAM

PIO4/FI1/BUS0/IO4

27

Y-Bus

X-Bus

C-Pointer
register

PIO5/FI2/BUS1/IO5

28

MAC

MZ

Y-Pointer
register

SRAM I/F

PIO6/FI3/BUS2/IO7

29

MY

register
XO X1 X2
Y0 Y1 Y2

X-Pointer
register

PO08/AD11 39
CROM
4k word

PO11/BUCK/AD14 36

MX

VDDM 40
CRAM
4k word

PIO7/BUS3/IO7

30

Instruction
Decoder

SRMSTB 41
ERAM
2k word

WE/SDO1

31

Program
Control

YRAM
4k word

PO10/CCE/AD13 37
Address Calc.
2sets

General
In/Output Port

32

PRAM

POM

XRAM
4k word

PO9/AD12 38
SRAM/
DRAM I/F

SDO3/OE 35

CDP Cont
I/F

AD15/CAS/PD12 34

AD4/PO04

HCD-GNX660

BD84 Board

IC301 TC94A34FG-002

25
24
23
22
21
20
19
18
17

CS/RAS/SDO2 33
16 LRCKIA

15 BCKIA

14 SDI0

13 LRCKO

12 BCKO

11 SDO0

10 VSS

9 VDDT

8 MIACK

VDDT 42
7 MICK

6 MIDIO

5 MILP

AD8 45

4 MICS

3 STANBY

PO06/AD6 47

2 RESET

Timing
Generator

1 VDDP

HCD-GNX660

ADC Board
IC11,12 PCM1803DBR

DELTA-SIGMA
MODULATOR

L IN 1

20 MODE 1

R IN 2

x1/64, x1/128
DECIMATION
FILTER
WITH
HIGH-PASS FILTER

V_REF_1 3
REFERENCE

V_REF_2 4

MODE/
FORMAT
CONTROL

19 MODE 0
18 FMT 1
17 FMT 0

SERIAL
INTERFACE

DELTA-SIGMA
MODULATOR

16 TEST

VCC 5
POWER SUPPLY

15 SCKI

CLOCK AND TIMING CONTROL

AGND 6

14 VDD
13 DGND

PDWN 7

12 DOUT

BYPASS 8

11 BCK

FSYNC 9
LRCK 10

OVF FLAGL

INIT

SFLAG

LRCK

MCKSEL

BCK

DATA

BFVSS

BFVDD

DVDD

XFSIIN

IC500,600 CXD9843AR

TEST

SMASTER Board

36 35 34 33 32 31 30 29 28 27 26 25

SAMPLING RATE
CONVERTER

FSOCKO 37
FSOI 38

CLOCK GENERATOR
(PRIMARY CLOCK SYSTTEM)

HPOUTR2 39

DF1

DF2

HPVSSR 40
HPOUTR1 41
HPVDDR 42

PWM

CONVERTER

HPOUTL2 43

LINER
INTERPOLATOR

GAIN
CONTROL

FILTER
&
LOW CUT FILTER

HPVSSL 44
24 OVF FLAGR

HPOUTL1 45

23 SCLATCH

HPVDDL 46

SERIAL
CONTROL

XVDD 47

22 SCSHIFT
21 SCDT

XFSOIN 48

20 PGMUTE
CLOCK GENERATOR
(SECONDARY CLOCK SYSTEM)

INIT/MUTE

19 SOFTMUTE
18 NSPMUTE
17 DVSS
16 DVDD
15 XOVDD
14 XFSOOUT

9 10 11 12

VSSR

VSSL

OUTL2

VDDL

OUTL1
VSSL

VDDR

OUTR1

XVSS

VSSR

OUTR2

VSUBC

13 XOVSS

55

HCD-GNX660

7-28. IC Pin Function Descriptions

IC101 CXD3059AR (RF AMP,DSP,DAC) (BD84 BOARD)
Pin No.

Pin Name

I/O

MIRR

I/O

Not used (Open)

DFCT

I/O

Not used (Open)

FOK

I/O

Not used (Open)

56

Description

VSS

Ground terminal

LOCK

I/O

Not used (Open)

MDP

Spindle motor servo control signal output

SSTP

Disc innermost detection signal input

IOVSS1

Ground terminal

SFDR

Sled drive signal output

10

SRDR

Sled drive signal output

11

TFDR

Tracking drive signal output

12

TRDR

Tracking drive signal output

13

FFDR

Focus drive signal output

14

FRDR

Focus drive signal output

15

IOVDD1

Power supply terminal (+3.3V)

16

AVDD0

Power supply terminal (+3.3V)

17

AVSS0

Ground terminal

18

NC

Not used (Open)

19

E signal input

20

F signal input

21

TEI

Tracking error signal input

22

TEO

Tracking error signal output

23

FEI

Focus error signal input

24

FEO

Focus error signal output

25

VC

Center voltage output from RF amplifier block

26

A signal input

27

B signal input

28

C signal input

29

D signal input

30

NC

Not used (Open)

31

AVDD4

Power supply terminal (+3.3V)

32

RFDCO

RFDC signal output (Open)

33

PDSENS

Reference voltage terminal

34

AC_SUM

RFAC summing amplifier signal output

35

EG_IN

Equalizer circuit signal input

36

LD

APC LD drive signal output

37

PD

APC PD signal input

38

NC

Not used (Open)

39

RFC

Equalizer cut-off frequency adjustment terminal

40

AVSS4

Ground terminal

41

RFACO

RFAC signal output

42

RFACI

RFAC signal input or EFM signal input

43

AVDD3

Power supply terminal (+3.3V)

44

BIAS

Asymmetry circuit constant current input

45

ASYI

Asymmetry comparator voltage input

46

ASYO

EFM full-swing signal output

47

VPCO

Not used (Open)

48

VCTL

Wide-band EFM PLL VCO2 control voltage input

HCD-GNX660

Pin No.

Pin Name

I/O

Description

49

AVSS3

Ground terminal

50

CLTV

Multiplier VCO1 control voltage input

51

FILO

Master PLL (slave = digital PLL) filter signal output

52

FILI

Master PLL filter signal input

53

PCO

Master PLL charge pump signal output

54

AVDD5

Power supply terminal (+3.3V)

55

DDVROUT

DC/DC converter output (+2.5V)

56

DDVRSEN

DC/DC converter output voltage monitor signal input

57

AVSS5

Ground terminal

58

DDCR

DC/DC converter reset signal input

59

NC

Not used (Open)

60

BCKI

D/A interface bit clock input

61

PCMDI

D/A interface serial data input

62

LRCKl

D/A interface LR clock input

63

LRCK

D/A interface LR clock output f = Fs

64

VSS

Ground terminal

65

PCMD

D/A interface serial data output

66

BCK

D/A interface bit clock output

67

VDD

Power supply terminal (+2.5V)

68

EMPH

High when the playback disc has emphasis, low it has not

69

EMPHI

High when de-emphasis is ON, low when input OFF

70

IOVDD2

Power supply terminal (+3.3V)

71

DOUT

Digital Out signal output

72

TEST

Test terminal (Connected to ground)

73

TEST1

Test terminal (Connected to ground)

74

IOVSS2

Ground terminal

75

NC

Not used (Open)

76

XVSS

Ground terminal

77

XTAO

Crystal oscillation circuit signal output

78

XTAI

Crystal oscillation circuit signal input

79

XVDD

Power supply terminal (+2.5V)

80

AVDD1

Power supply terminal (+3.3V)

81

AOUT1

L-ch analog signal output

82

VREFL

L-ch reference voltage output

83

AVSS1

Ground terminal

84

AVSS2

Ground terminal

85

VREFR

R-ch reference voltage output

86

AOUT2

R-ch analog signal output

87

AVDD2

Power supply terminal (+3.3V)

88

NC

Not used (Open)

89

IOVDD0

Power supply terminal (+3.3V)

90

RMUT

Not used (Open)

91

LMUT

Not used (Open)

92

NC

Not used (Open)

93

XTSL

Crystal selection signal input (Pull down)

94

IOVSS0

Ground terminal

95

XTACN

Oscillation circuit control signal input (H: self-oscillation, L: oscillation stop)

96

SQSO

Not used (Open)

97

SQCK

SQSO readout clock input (Connected to +VDD(+3.3V))

98

SBSO

Not used (Open)

57

HCD-GNX660

Pin No.

Pin Name

I/O

99

EXCK

Not used (Open)

100

XRST

System reset signal input from M30622MEP

101

SYSM

Muting signal input (Connected to ground)

102

DATA

Serial data input from M30622MEP

103

VSS

Ground terminal

58

Description

104

XLAT

Latch signal input from M30622MEP

105

CLOCK

Serial data transfer clock input from M30622MEP

106

VDD

Power supply terminal (+2.5V)

107

SENS

SENS output to M30622MEP

108

SCLK

SENS serial data readout clock input (Connected to +VDD(+3.3v))

109

ATSK

I/O

Not used (Open)

110

WFCK

Not used (Open)

111

XUGF

Not used (Open)

112

XPCK

Not used (Open)

113

GFS

Not used (Open)

114

C2PO

Not used (Open)

115

SCOR

High output when the sub code sync, S0 or S1, is detected

116

VDD

Power supply terminal (+2.5V)

117

C4M

Not used (Open)

118

WDCK

Not used (Open)

119

COUT

I/O

Not used (Open)

120

NC

Not used (Open)

HCD-GNX660
Ver. 1.1

IC401 M30622MGP-A54FPU0 SYSTEM CONTROL (MAIN BOARD)

Pin No.

Pin Name

I/O

Description

BD-RST

Reset signal output to the digital signal processor ( L:reset)

CD-DATA-OUT

Serial data output to the digital signal processor

XLAT

Serial data latch pulse output to the digital signal processor

SIRCS

Remote control signal input

MP3-DATA-OUT

Serial data output signal to MP3 decoder IC

MP3-DATA-IN

Serial data input signal from MP3 decoder IC

MP3-CLK

Serial data transfer clock signal to MP3 decoder IC

BYTE

Ground terminal

CNVSS

Ground terminal

10

XC-IN

Sub system clock input terminal (32.768kHz)

11

XC-OUT

Sub system clock output terminal (32.768kHz)

12

RESET

System reset signal input from the reset signal IC (L: reset) After the power supply

13

X-OUT

Main system clock output terminal (5MHz)

rises, L is input for several hundreds msec and then change to H.

14

VSS

Ground terminal

15

X-IN

Main system clock input terminal (5MHz)

16

VCC

Power supply terminal (+3.3V)

17

NMI

Non-maskable interrupt input terminal (Pull to +3.3V)

18

NO-USE

Unused port (Pull to ground)

19

SCOR

Subcode sync (S0+S1) detection signal input from the digital signal processor

20

AC-CUT

C off detection signal input from the reset signal IC (L: AC cut detected)

21

SENS

Internal status detection monitor input from the digital signal processor

22

MP3-RST

Reset signal output to MP3 decoder IC

23

MP3-CS

Chip select output signal to MP3 decoder IC (L:enable)

24

MP3-LP

Latch output signal to MP3 decoder IC (L:enable)

25

MP3-ACK

Acknowledgement input signal from MP3 decoder IC (L:acknowledged)

26

MP3-REQ

Request signal from MP3 decoder IC

27

MP3-STB

Standby mode signal output to MP3 decoder IC (L:standby mode)

28

XTACN

29

IIC-CLK

I/O

Clock signal for IIC communcation between the microcomputer and the IIC checker

BD DSP oscillation on/off control signal output (H:on)

30

IIC-DATA

I/O

Data signal for IIC communcation between the microcomputer and the IIC checker

31

VMUTE

CDG video signal muting on/off control signal output (H: muting on)

32

CDG-DET

CDG disc detection signal input from CDG decoder (H: CDG disc detected)

33

CDG-RST

Reset signal output to the CDG decoder (L:reset)

34

CD-MUTE

CD analog signal muting on/off control signal output (H:muting on)

35

CD-POWER

Power on/off control signal output to BU section (H:power on)

36

ST-CE

PLL chip enable signal output to the tuner unit

37

ST-DOUT/MC-DIN

PLL serial data input from the tuner unit

38

ST-CLK

PLL serial data transfer clock signal output to the tuner unit

39

ST-DIN/MC-DOUT

PLL serial data output to the tuner unit

40

TUNED

Tuning detection signal input from the tuner unit (L:tuned)

41

OPEN-SW

Eject detection signal input from the CD mechanism deck

42

TBL-SENSE

Disc tray position detection signal input from the CD mechanism deck

43

E-3

Disc tray status detection signal input from the CD mechanism deck

44

E-2

Disc tray status detection signal input from the CD mechanism deck

45

E-1

Disc tray status detection signal input from the CD mechanism deck

46

TM-F

Turning motor control signal output to the CD mechanism deck

47

TM-R

Turning motor control signal output to the CD mechanism deck

59

HCD-GNX660
Pin No.

Pin Name

I/O

Description

48

LM-F

Loading motor control signal output to the CD mechanism deck

49

LM-R

Loading motor control signal output to the CD mechanism deck

50

LED-ILLUMINATION-1

Dynamic LED drive signal output to the ILLUMINATION 1st indicator and 2nd
indicator

51

LED-ILLUMINATION-2

Dynamic LED drive signal output to the ILLUMINATION 3rd indicator and 4th

52

LED-ILLUMINATION-3

53

LED-CTRL

Dynamic LED drive select signal output

54

VOL-A

Jog dial pulse input from the VOLUME rotary encoder (A phase input)

indicator
Dynamic LED drive signal output to the ILLUMINATION 5th indicator and 6h indicator

55

VOL-B

Jog dial pulse input from the VOLUME rotary encoder (B phase input)

56

STBY-LED

LED drive signal output of POWER indicator (H:LED is turned on)

57

FL-DRIVER-DATA

Serial data output signal to FL Driver, NJU3427

58

FL-DRIVER-CLK

Serial data clock signal to FL Driver, NJU3427

59

FL-DRIVER-RESET

Serial data reset signal to FL Driver, NJU3427

60

FL-DRIVER-CS

Serial data chip select signal to FL Driver, NJU3427

61

SW-LED

LED drive signal output of SUB WOOFER ON indicator (H:LED on)

62

VCC

Power supply terminal (+3.3V)

63

A-HALF

Deck A cassette detection signal input terminal (H:cassette detected)

64

VSS

Ground terminal

65

SM-RESET

Reset signal output to the S-Master Power IC

66

IO-EXP-DATA-OUT

Serial data output signal to IO expander, BH2210V

67

NO-USE

Unused port (Pull to ground)

68

IO-EXP-RST

Reset signal output to the I/O expander, BH2210V

69

IO-EXP-CLK

Serial data latch signal to I/O expander, BH2210V

70

IO-EXP-LAT

Serial data clock signal to I/O expander, BH2210V

71

NO-USE

Unused port (Pull to ground)

72

SM-SD

Shutdown (protector) detection signal from the S-Master Power IC

73

DISPLAY-KEY

DISPLAY key press detection signal (Interrupt input)

74

POWER-KEY

POWER key press detection signal (Interrupt input)

75

NO-USE

Unused port (Pull to ground)

76

SM-LATCH-1

Serial data latch pulse output to the S-Master Processor IC (Front channel)

77

SM-CLK

Serial data transfer clock signal to the S-Master Processor IC

78

SM-DATA

Serial data output signal to the S-Master Processor IC

79

SM-LATCH-2

Serial data latch pulse output to the S-Master Processor IC (Sub woofer channel)

80

NO-USE

Unused port (Pull to ground)

81

NO-USE

Unused port (Pull to ground)

82

CD-CLK

Serial data transfer clock signal output to the digital signal processor

83

M61537-DATA

Serial data output to audio signal processor, M61537FP

84

M61537-CLK

Serial data transfer clock signal output to audio signal processor, M61537FP

85

HP DET

Headphone connection detection signal input H: headphone connected

86

HP-MUTE

Headphone muting on/off control signal (L: muting on)

87

NO-USE

Unused port (Pull to ground)

88

VACS-IN

VACS level detection signal (A/D input)

89

A-SHUT

Shut off detection signal input from deck A side reel pulse detector (A/D input)

90

B-SHUT

Shut off detection signal input from deck B side reel pulse detector (A/D input)

91

B-HALF

Deck B cassette detection and forward side recording tab detection signal input
terminal (A/D input)

60

92

MODEL-IN

Model setting terminal (A/D input)

93

DEST-IN

Destination setting terminal (A/D input)

94

AD-KEY-3

Key input terminal (A/D input)

95

AD-KEY-2

Key input terminal (A/D input)

HCD-GNX660

Pin No.

Pin Name

I/O

96

AVSS

Ground terminal (for A/D conversion)

Description

97

AD-KEY-1

Key input terminal (A/D input)

98

VREF

A/D Converter reference voltage input terminal (+3.3V)

99

AVCC

Power supply terminal (+3.3V) (for A/D conversion)

100

MAIN ON/OFF

Main power on/off control signal output (H:power on)

61

HCD-GNX660

IC403 BH2210FV-E2 (SIGNAL IN/OUT CONTROL) (MAIN BOARD)

Pin No.

Pin Name

I/O

Description

CTLIO

Input/output mode select port (Fixed at "H")

RESET

Reset signal input

CLK

Serial data clock input

LATCH

Serial data latch input

TC-MUTE

Tape playback muting on/off control signal output ( "H":muting on)

NO-USE

Not used (Open)

REC-MUTE

Recording muting on/off control signal output ("H":muting on)

NO-USE

Not used (Open)

SM-NSP-MUTING

S-Master Processor IC PWM 50% duty muting on/off control signal output
("L":muting on)

62

10

SM-SOFT-MUTING

S-Master Processor IC Soft muting on/off control signal output ("L":muting on)

11

NO USE

Not used (Open)

12

SM-INIT

Initialization signal output to the S-Master Processor IC

13

LATCHO

Serial data latch output signal (Not used) (Open)

14

CLKO

Serial data clock output signal (Not used) (Open)

15

DO1

Serial data output signal 1 (Not used) (Open)

16

DI2

Serial data input signal 2 (Not used) (Open)

17

A-TRIG

Deck A side trigger plunger drive signal output ("H":plunger on)

18

CAPM-CNT

Capstan motor drive signal output

19

B-TRIG

Deck B side trigger plunger drive signal output ("H":plunger on)

20

REC-BIAS

Recording bias on/off control signal output ("H":bias on)

21

TC-RELAY

Recording/playback selection signal output ("H":recording "L":playback)

22

ADC-RESET

Power down control signal to Analog to Digital converter, PCM1803 ("L": Power down)

23

NO-USE

Not used (Open)

24

FAN-CTRL

Fan driving signal output ("L": Fan on)

25

DO2

Serial data output signal 2 (Not used) (Open)

26

DI1

Serial data input signal 1

27

VSS

Ground terminal

28

VDD

Power supply terminal (+3.3V)

HCD-GNX660
SECTION 8
EXPLODED VIEWS
NOTE:
-XX, -X mean standardized parts, so they may
have some differences from the original one.
Items marked * are not stocked since they
are seldom required for routine service. Some
delay should be anticipated when ordering these
items.
The mechanical parts with no reference number
in the exploded views are not supplied.

8-1.

Hardware (# mark) list and accessories are

given in the last of this parts list.

The components identified by mark 0 or

dotted line with mark 0 are critical for
safety.
Replace only with part number specified.

CASE (TOP), BACK PANEL SECTION

#1

#1

5
6

2
1
13
6

7
#1

not supplied

not supplied

8
#1

15

6
#1

#1
not
supplied

#1

10

#1

#1
#1
#1

not supplied

14
#1
not supplied

M891

11
#1

#1

3
12
9
2

Ref. No.

Part No.

Description

1
2
3
4
5

2-658-345-11
3-363-099-02
3-363-099-32
2-680-202-01
2-670-216-01

PANEL, LOADING
SCREW (CASE 3 TP2)
SCREW (CASE 3 TP2)
CASE (SIDE-L)
CASE (TOP)

6
7
8
9

3-703-136-12
1-693-702-11
2-630-050-01
2-680-201-01

SCREW, TAPPING
TUNER (FM/AM) (TM10SE)
+BVTT 3X6 (SUMITITE)
CASE (SIDE-R)

Remarks

Ref. No.

Part No.

Description

10

1-775-284-11 WIRE (FLAT TYPE) (31 CORE)

11
12
13
14
15

1-829-030-11
1-827-720-11
3-378-109-12
1-828-973-11
A-1164-015-A

M891
#1

1-763-072-11 FAN, DC
7-685-646-79 SCREW +BVTP 3X8 TYPE2 TT (B)

Remarks

WIRE (FLAT TYPE) (25 CORE)

WIRE (FLAT TYPE) (11 CORE)
CUSHION, SARANET
WIRE (FLAT TYPE) (13 CORE)
CDG BOARD, COMPLETE

63

HCD-GNX660

8-2.

FRONT PANEL SECTION

65
63

65

not
supplied

62

65

not
supplied

61
75
60

76

74

59

64

73
58
72

57

55
supplied
with S1305

53

59

71
66

54
70

65

56
65

53

52

69

not
supplied

68

67

51
#1

Ref. No.

Part No.

Description

51
52
53
54
55

2-658-356-01
2-658-355-01
2-669-613-01
2-590-671-01
X-2103-595-1

HOLDER (TC-R)
HOLDER (TC-L)
DETENT SPRING
KNOB (VOL)
KNOB JOG ASSY

56
57
58
59
60

4-238-628-03
2-658-350-01
4-231-841-01
4-224-104-41
4-231-825-01

MIC KNOB
WINDOW (FL)
SPRING (HEART CAM-B)
DAMPER
CAM (B), HEART

61
62
63
64

2-658-343-11
X-2103-443-1
A-1167-717-A
2-658-347-01

PANEL, FRONT
BUTTON (FUNCTION) ASSY
PANEL BOARD, COMPLETE
BUTTON (DISC)

64

Remarks

Ref. No.
65

Part No.
Description
3-087-053-01 +BVTP2.6 (3CR)

66
67
68
69
70

1-417-656-11
A-1167-713-A
4-225-252-01
2-658-367-01
4-231-836-01

MECHA DECK (CWN42FF601)

MIC BOARD, COMPLETE
CUSHON (FOOT)
SPRING (L)
SPRING (HEART CAM-A)

71
72
73
74
75

2-658-368-01
4-231-824-01
2-659-548-01
2-658-354-01
2-658-349-01

SPRING (R)
CAM (A), HEART
BUTTON (EQ2)
BUTTON (EQ)
BUTTON (DISPLAY)

76
#1

2-658-348-01 BUTTON (REC)

7-685-646-79 SCREW +BVTP 3X8 TYPE2 TT (B)

Remarks

HCD-GNX660
8-3.

CHASSIS SECTION

101
not supplied

not supplied

#1

104
101

101
102

108

not
supplied

107
#1

102
#1

101

106
105

not
supplied
#1
#1 F1100

101
103

not supplied

#1
not supplied

101

111
not supplied

101

111

109
110
not supplied

Ref. No.
101
102
103
104
105
106
* 107

Part No.

Description

2-630-050-01
3-703-136-12
A-1167-598-A
2-597-972-31
A-1164-113-A

+BVTT 3X6 (SUMITITE)

SCREW, TAPPING
POWER BOARD, COMPLETE
SHEET, RADIATION
SMASTER BOARD, COMPLETE

1-500-497-11 FILTER, CLAMP (FERRITE CORE)

3-703-571-12 BUSHING (S) (4516), CORD

Remarks

Ref. No.

Part No.

Description

0 108
109
110

1-827-226-31 CORD, POWER

A-1164-115-A ADC BOARD, COMPLETE
A-1159-558-A MAIN BOARD, COMPLETE

111
0 F1100
#1

4-225-252-01 CUSHION (FOOT)

1-532-506-33 FUSE (T6.3AL/250V)
7-685-646-79 SCREW +BVTP 3X8 TYPE2 TT (B)

#1

Remarks

65

HCD-GNX660

8-4. CD MECHANISM DECK SECTION-1

156

162

158

151
156

157
156

157

163

159

158
161

164
164
165

160

155
155

M741

152
154
153
166
CD mechanism deck section-2

151

Ref. No.
151
152
153
154
155

Part No.
4-218-253-62
1-832-798-21
1-687-134-12
4-243-815-11
4-245-571-02

Description
SCREW (M2.6), +BTTP
CABLE, FLEXIBLE FLAT (5 CORE)
MOTOR (TB) BOARD
TABLE (LOADING)
GEAR (STOPPER)

156
157
158
159

4-985-672-01
4-245-570-01
4-245-572-01
1-687-132-12

SCREW (+PTPWH M2.6), FLOATING

GEAR (JOINT)
BUSHING (GEAR)
SENSOR BOARD

66

Remarks

Ref. No.
160

Part No.
Description
4-243-820-01 GEAR (TABLE)

161
162
163
164
165

4-243-819-01
4-243-816-11
4-243-823-11
4-218-252-61
4-243-821-01

GEAR (GENEVA)
TRAY
BELT (TABLE)
SCREW (+PTPWH M2.6), FLOATING
PULLEY (TABLE)

166
M741

3-231-598-01 SHEET (BA)

A-1108-965-A MOTOR ASSY, TABLE (TABLE)

Remarks

HCD-GNX660

8-5.

CD MECHANISM DECK SECTION-2

212

205

213

205
216
214

211

217

205
215

210

219

231

220

S711

202
208
222
229

205
223
222

222

M751

230

223
223
222
223 205 205

207
203
206

218

202

205

205
201
202

226

228

204
not supplied

232

Ref. No.

Part No.

Description

201
202
203
204
205

A-1103-756-B
4-218-253-52
1-687-669-12
4-244-034-11
4-985-672-01

DRIVER BOARD, COMPLETE

SCREW (M2.6), +BTTP
SW BOARD
BELT (LOADING)
SCREW (+PTPWH M2.6), FLOATING

206
207
208
210
211

4-225-844-01
4-224-613-11
1-687-133-12
4-244-108-01
4-224-609-01

GEAR (LOADING A)
GEAR (SHAFT)
MOTOR (LD) BOARD
GEAR, SWING
GEAR (LOADING C)

212
213
214
215
216

4-224-608-01
3-016-533-11
4-224-611-01
4-224-606-01
4-243-818-01

COLLAR, SWING
WASHER (FR), STOPPER
GEAR (LOADING B)
GEAR (RV)
GEAR (U/D)

Remarks

Ref. No.

Part No.

Description

217
218
219
220
222

4-243-822-02
X-2102-809-2
4-231-189-01
X-2055-190-1
4-227-549-11

LEVER (LIFTER)
PULLEY (KH) ASSY
PULLEY (B), CHUCKING
HOLDER (213) ASSY
INSULATOR

223
226
228
0 229
230

4-227-045-31
1-832-404-21
A-1095-982-A
8-820-244-01
1-471-035-21

SPRING (INSULATOR), COIL

CABLE, FLEXIBLE FLAT (16 CORE)
BD84 BOARD, COMPLETE
OPTICAL PICK-UP KSM-215DCP/C2NP
MAGNET ASSY

4-243-817-22
3-087-053-01
A-1108-966-A
1-477-680-12

CHASSIS
+BVTP2.6 (3CR)
MOTOR ASSY, LOADING (LOADING)
ENCODER, ROTARY

231
232
M751
S711

Remarks

67

HCD-GNX660
Ver. 1.1
ADC

SECTION 9
ELECTRICAL PARTS LIST

NOTE:
Due to standardization, replacements in the
parts list may be different from the parts
specified in the diagrams or the components
used on the set.
-XX, -X mean standardized parts, so they
may have some difference from the original
one.
Items marked * are not stocked since they
are seldom required for routine service.
Some delay should be anticipated when
ordering these items.
CAPACITORS:
uF: F
Ref. No.
Part No.
Description

RESISTORS
All resistors are in ohms.
METAL: metal-film resistor
METAL OXIDE: Metal Oxide-film resistor
F: nonflammable
COILS
uH: H
SEMICONDUCTORS
In each case, u: , for example:
uA...: A... , uPA... , PA... ,
uPB... , PB... , uPC... , PC... ,
uPD..., PD...
Remarks

Ref. No.

Part No.

A-1164-115-A ADC BOARD, COMPLETE

********************

The components identified by mark 0

or dotted line with mark 0 are critical
for safety.
Replace only with part number specified.
When indicating parts by reference
number, please include the board.

Description

Remarks

< DIODE >

< CAPACITOR >

D11
D12
D13
D14
D51

8-719-988-61
8-719-988-61
8-719-988-61
8-719-988-61
8-719-988-61

D52
D61

8-719-988-61 DIODE 1SS355TE-17

8-719-988-61 DIODE 1SS355TE-17

C20
C22
C23
C24
C25

1-126-956-91
1-104-658-91
1-107-826-11
1-104-658-91
1-107-726-91

ELECT
ELECT
CERAMIC CHIP
ELECT
CERAMIC CHIP

0.1uF
100uF
0.1uF
100uF
0.01uF

20%
20%
10%
20%
10%

50V
10V
16V
10V
16V

C26
C27
C28
C29
C32

1-107-826-11
1-126-963-11
1-162-915-11
1-162-915-11
1-107-726-91

CERAMIC CHIP
ELECT
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP

0.1uF
4.7uF
10PF
10PF
0.01uF

10%
20%
0.5PF
0.5PF
10%

16V
50V
50V
50V
16V

C40
C41
C42
C50
C51

1-164-156-11
1-164-156-11
1-164-156-11
1-164-156-11
1-126-964-11

CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
ELECT

0.1uF
0.1uF
0.1uF
0.1uF
10uF

FL01
FL02

20%

25V
25V
25V
25V
50V

C53
C54
C55
C56
C57

1-104-658-91
1-164-156-11
1-126-964-11
1-164-156-11
1-126-964-11

ELECT
CERAMIC CHIP
ELECT
CERAMIC CHIP
ELECT

100uF
0.1uF
10uF
0.1uF
10uF

10V
25V
50V
25V
50V

IC01
IC02
IC03
IC11
IC12

C58
C59
C60
C61
C62

1-164-156-11
1-126-960-11
1-126-960-11
1-164-156-11
1-126-964-11

CERAMIC CHIP
ELECT
ELECT
CERAMIC CHIP
ELECT

0.1uF
1uF
1uF
0.1uF
10uF

C63
C64
C65
C66
C67

1-126-964-11
1-164-156-11
1-126-964-11
1-164-156-11
1-104-658-91

ELECT
CERAMIC CHIP
ELECT
CERAMIC CHIP
ELECT

10uF
0.1uF
10uF
0.1uF
100uF

C68
C70
C81
C90
C91

1-164-156-11
1-126-960-11
1-107-726-91
1-162-964-11
1-162-964-11

CERAMIC CHIP
ELECT
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP

C93

1-162-964-11 CERAMIC CHIP

DIODE
DIODE
DIODE
DIODE
DIODE

1SS355TE-17
1SS355TE-17
1SS355TE-17
1SS355TE-17
1SS355TE-17

< EARTH TERMINAL >

EP01
EP02

1-537-738-21 TERMINAL, GROUND

1-537-738-21 TERMINAL, GROUND
< FILTER >

20%
20%
20%

20%
20%
20%
20%

20%

50V
25V
50V
25V
10V

0.1uF
1uF
0.01uF
0.001uF
0.001uF

20%
10%
10%
10%

25V
50V
16V
50V
50V

0.001uF

10%

50V

20%

< CONNECTOR >

CN01

68

25V
50V
50V
25V
50V

1-766-720-41 CONNECTOR, BOARD TO BOARD 17P

1-234-177-21 FILTER, CHIP EMI

1-234-177-21 FILTER, CHIP EMI
< IC >
8-759-473-95
8-759-583-47
8-759-387-77
6-707-608-01
6-707-608-01

IC
IC
IC
IC
IC

uPC2905T-E1
uPC2933T-E2
TC7WU04F (TE12R)
PCM1803DBR
PCM1803DBR

< JUMPER RESISTOR >

JR21
JR51
JR52

1-216-864-11 SHORT CHIP

1-216-806-11 METAL CHIP
1-216-806-11 METAL CHIP

0
56
56

5%
5%

1/10W
1/10W

5%
5%
5%
5%

1/10W
1/10W
1/10W
1/10W

5%
5%

1/10W
1/10W

5%

1/10W

< COIL >

L01
L02
L03

1-412-939-11 INDUCTOR
1-412-951-11 INDUCTOR
1-412-951-11 INDUCTOR

1uH
10uH
10uH

< RESISTOR >

R25
R27
R29
R31
R36

1-216-825-11
1-216-845-11
1-216-825-11
1-216-845-11
1-216-864-11

METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
SHORT CHIP

2.2K
100K
2.2K
100K
0

R38
R40
R41
R50
R52

1-216-864-11
1-216-821-11
1-216-857-11
1-216-864-11
1-216-809-11

SHORT CHIP
METAL CHIP
METAL CHIP
SHORT CHIP
METAL CHIP

0
1K
1M
0
100

HCD-GNX660
ADC
Ref. No.

Part No.

Description

R53
R55
R57
R58
R59

1-216-809-11
1-216-864-11
1-216-864-11
1-216-864-11
1-216-864-11

METAL CHIP
SHORT CHIP
SHORT CHIP
SHORT CHIP
SHORT CHIP

100
0
0
0
0

Remarks

R60
R63
R64
R65
R67

1-216-864-11
1-216-809-11
1-216-864-11
1-216-864-11
1-216-864-11

SHORT CHIP
METAL CHIP
SHORT CHIP
SHORT CHIP
SHORT CHIP

0
100
0
0
0

5%

5%

1/10W

Part No.

Description

Remarks

C196

1-164-360-11 CERAMIC CHIP

0.1uF

16V

C201
C203
C209
C210
C211

1-128-995-21
1-128-995-21
1-162-970-11
1-107-826-11
1-164-230-11

ELECT CHIP
ELECT CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP

100uF
100uF
0.01uF
0.1uF
220PF

20%
20%
10%
10%
5%

10V
10V
25V
16V
50V

C212
C213
C251
C252
C255

1-162-919-11
1-162-919-11
1-162-969-11
1-164-360-11
1-164-360-11

CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP

22PF
5%
22PF
5%
0.0068uF 10%
0.1uF
0.1uF

50V
50V
25V
16V
16V

C257
C258
C259
C260
C302

1-164-360-11
1-164-360-11
1-164-360-11
1-128-394-11
1-164-360-11

CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
ELECT CHIP
CERAMIC CHIP

0.1uF
0.1uF
0.1uF
220uF
0.1uF

16V
16V
16V
10V
16V

C303
C305
C306
C307
C308

1-164-360-11
1-126-246-11
1-164-360-11
1-164-360-11
1-126-208-21

CERAMIC CHIP
ELECT CHIP
CERAMIC CHIP
CERAMIC CHIP
ELECT CHIP

0.1uF
220uF
0.1uF
0.1uF
47uF

C309
C310
C311
C312
C313

1-164-360-11
1-164-360-11
1-164-360-11
1-164-360-11
1-164-360-11

CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP

0.1uF
0.1uF
0.1uF
0.1uF
0.1uF

C314
C315
C316
C317
C318

1-126-208-21
1-107-826-11
1-162-966-11
1-162-970-11
1-162-970-11

ELECT CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP

47uF
0.1uF
0.0022uF
0.01uF
0.01uF

20%
10%
10%
10%
10%

4V
16V
50V
25V
25V

C320

1-162-964-11 CERAMIC CHIP

0.001uF

10%

50V

1/10W

< VIBRATOR >

X001
1-795-843-11 VIBRATOR, CRYSTAL (12.288MHz)
************************************************************
A-1095-982-A BD84 BOARD, COMPLETE
*********************
< CAPACITOR >
C10
C11
C14
C15
C16

1-165-989-11
1-165-989-11
1-164-360-11
1-164-360-11
1-115-156-11

CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP

10uF
10uF
0.1uF
0.1uF
1uF

10%
10%

C17
C18
C111
C112
C113

1-126-246-11
1-162-964-11
1-162-967-11
1-162-962-11
1-162-967-11

ELECT CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP

220uF
0.001uF
0.0033uF
470PF
0.0033uF

20%
10%
10%
10%
10%

4V
50V
50V
50V
50V

C114
C115
C116
C122
C123

1-162-962-11
1-164-360-11
1-128-995-21
1-107-826-11
1-107-826-11

CERAMIC CHIP
CERAMIC CHIP
ELECT CHIP
CERAMIC CHIP
CERAMIC CHIP

470PF
0.1uF
100uF
0.1uF
0.1uF

10%

50V
16V
10V
16V
16V

C124
C125
C131
C132
C133

1-162-959-11
1-164-360-11
1-162-927-11
1-117-863-11
1-162-970-11

CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP

330PF
0.1uF
100PF
0.47uF
0.01uF

5%
5%
10%
10%

50V
16V
50V
6.3V
25V

C134
C141
C142
C143
C151

1-164-360-11
1-107-826-11
1-162-965-11
1-164-360-11
1-128-995-21

CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
ELECT CHIP

0.1uF
0.1uF
10%
0.0015uF 10%
0.1uF
100uF
20%

16V
16V
50V
16V
10V

C161
C162
C163
C171
C172

1-164-360-11
1-164-360-11
1-164-360-11
1-162-919-11
1-162-920-11

CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP

0.1uF
0.1uF
0.1uF
22PF
27PF

5%
5%

16V
16V
16V
50V
50V

C174
C181
C182
C183
C184

1-164-360-11
1-164-360-11
1-164-360-11
1-124-778-00
1-124-778-00

CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
ELECT CHIP
ELECT CHIP

0.1uF
0.1uF
0.1uF
22uF
22uF

20%
20%

16V
16V
16V
6.3V
6.3V

C185
C186
C194
C195

1-162-962-11
1-162-962-11
1-164-360-11
1-164-360-11

CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP

470PF
470PF
0.1uF
0.1uF

20%
10%
10%

Ref. No.

BD84

6.3V
6.3V
16V
16V
10V

20%

20%

20%

16V
4V
16V
16V
4V
16V
16V
16V
16V
16V

< CONNECTOR >

CN101
CN201

1-770-425-51 CONNECTOR, FFC/FPC 16P

1-784-879-51 CONNECTOR, FFC (LIF (NON-ZIF)) 31P
< FERRITE BEAD >

10%
10%

50V
50V
16V
16V

FB301

1-500-445-21 FERRITE, EMI (SMD) (2012)

< IC >

IC101
IC251
IC301
IC303

8-752-425-12
6-705-808-01
6-705-365-01
6-705-807-01

IC
IC
IC
IC

CXD3059AR
BA5947FM-E2
TC94A34FG-002
BH15FB1WG

< TRANSISTOR >

Q10

6-551-120-01 TRANSISTOR 2SA2119K

< RESISTOR >

R10
R11
R12
R13
R111

1-216-791-11
1-216-864-11
1-216-845-11
1-218-446-11
1-216-821-11

METAL CHIP
SHORT CHIP
METAL CHIP
METAL CHIP
METAL CHIP

3.3
0
100K
1
1K

5%

1/10W

5%
5%
5%

1/10W
1/10W
1/10W

69

HCD-GNX660
BD84
Ref. No.

CDG
Part No.

Description

R112
R113
R114
R121
R131

1-216-835-11
1-216-821-11
1-216-835-11
1-216-835-11
1-216-857-11

METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP

15K
1K
15K
15K
1M

5%
5%
5%
5%
5%

1/10W
1/10W
1/10W
1/10W
1/10W

Remarks

R132
R133
R141
R142
R143

1-216-833-11
1-216-848-11
1-216-829-11
1-216-821-11
1-216-827-11

METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP

10K
180K
4.7K
1K
3.3K

5%
5%
5%
5%
5%

1/10W
1/10W
1/10W
1/10W
1/10W

R151
R161
R162
R163
R165

1-216-864-11
1-216-809-11
1-216-841-11
1-216-809-11
1-216-864-11

SHORT CHIP
METAL CHIP
METAL CHIP
METAL CHIP
SHORT CHIP

0
100
47K
100
0

5%
5%
5%

1/10W
1/10W
1/10W

R171
R172
R173
R181
R182

1-216-817-11
1-216-857-11
1-216-295-91
1-216-809-11
1-216-809-11

METAL CHIP
METAL CHIP
SHORT CHIP
METAL CHIP
METAL CHIP

470
1M
0
100
100

5%
5%

1/10W
1/10W

5%
5%

1/10W
1/10W

R191
R201
R203
R204
R205

1-216-864-11
1-500-445-21
1-216-864-11
1-216-864-11
1-216-864-11

SHORT CHIP
0
FERRITE, EMI (SMD) (2012)
SHORT CHIP
0
SHORT CHIP
0
SHORT CHIP
0

R251
R252
R253
R301
R302

1-216-833-11
1-216-837-11
1-216-833-11
1-216-845-11
1-216-833-11

METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP

10K
22K
10K
100K
10K

5%
5%
5%
5%
5%

1/10W
1/10W
1/10W
1/10W
1/10W

R303
R305
R306
R307
R313

1-216-845-11
1-216-845-11
1-216-864-11
1-216-833-11
1-216-813-11

METAL CHIP
METAL CHIP
SHORT CHIP
METAL CHIP
METAL CHIP

100K
100K
0
10K
220

5%
5%

1/10W
1/10W

5%
5%

1/10W
1/10W

R351
R352
R353
R354
R401

1-216-809-11
1-216-809-11
1-216-809-11
1-216-809-11
1-216-809-11

METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP

100
100
100
100
100

5%
5%
5%
5%
5%

1/10W
1/10W
1/10W
1/10W
1/10W

R402
R403
R404
R405
R406

1-216-809-11
1-216-809-11
1-216-809-11
1-216-809-11
1-216-809-11

METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP

100
100
100
100
100

5%
5%
5%
5%
5%

1/10W
1/10W
1/10W
1/10W
1/10W

R407
R408
R409
R410
R411

1-216-809-11
1-216-809-11
1-216-809-11
1-216-809-11
1-216-809-11

METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP

100
100
100
100
100

5%
5%
5%
5%
5%

1/10W
1/10W
1/10W
1/10W
1/10W

R412
R419
R421
R422
R423

1-216-809-11
1-216-809-11
1-216-809-11
1-216-809-11
1-216-809-11

METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP

100
100
100
100
100

5%
5%
5%
5%
5%

1/10W
1/10W
1/10W
1/10W
1/10W

Ref. No.

Description

Remarks

< SWITCH >

S101

1-771-853-11 SWITCH, DETECTION (LIMIT)

< VIBRATOR >

X171
1-767-408-21 VIBRATOR, CRYSTAL (16.9344MHZ)
************************************************************
A-1164-015-A CDG BOARD, COMPLETE
********************
< CAPACITOR >
C1001
C1002
C1003
C1004
C1005

1-162-970-11
1-162-970-11
1-162-970-11
1-162-970-11
1-162-970-11

CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP

0.01uF
0.01uF
0.01uF
0.01uF
0.01uF

10%
10%
10%
10%
10%

25V
25V
25V
25V
25V

C1006
C1007
C1008
C1010
C1011

1-162-970-11
1-162-970-11
1-126-960-11
1-104-658-91
1-162-970-11

CERAMIC CHIP
CERAMIC CHIP
ELECT
ELECT
CERAMIC CHIP

0.01uF
0.01uF
1uF
100uF
0.01uF

10%
10%
20%
20%
10%

25V
25V
50V
10V
25V

C1012
C1013
C1014
C1015
C1018

1-126-947-11
1-104-658-91
1-162-970-11
1-162-970-11
1-162-919-11

ELECT
ELECT
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP

47uF
100uF
0.01uF
0.01uF
22PF

20%
20%
10%
10%
5%

35V
10V
25V
25V
50V

C1019
C1021
C1022
C1023
C1024

1-162-919-11
1-162-971-11
1-162-919-11
1-126-960-11
1-104-658-91

CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
ELECT
ELECT

22PF
0.001uF
22PF
1uF
100uF

5%
10%
5%
20%
20%

50V
50V
50V
50V
10V

C1025
C1026
C1027
C1028
C1029

1-162-970-11
1-104-655-91
1-162-957-11
1-104-658-91
1-165-647-91

CERAMIC CHIP
ELECT
CERAMIC CHIP
ELECT
CERAMIC CHIP

0.01uF
470uF
220PF
100uF
0.47uF

10%
20%
5%
20%
10%

25V
6.3V
50V
10V
6.3V

C1030
C1036
C1037
C1038
C1039

1-126-965-91
1-162-957-11
1-162-957-11
1-162-957-11
1-162-957-11

ELECT
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP

22uF
220PF
220PF
220PF
220PF

20%
5%
5%
5%
5%

50V
50V
50V
50V
50V

< CONNECTOR >

* CN1001 1-784-774-11 CONNECTOR, FFC 13P
CN1003 1-785-314-11 PIN, CONNECTOR (STRAIGHT) 2P
< DIODE >
D1003
D1004

6-501-193-01 DIODE 1SS355WTE-17

6-501-193-01 DIODE 1SS355WTE-17
< FERRITE BEAD >

FB1001 1-216-864-11 SHORT CHIP

< IC >
IC1001
IC1002

70

Part No.

6-707-420-01 IC TC9411AFG (BS, K)

6-704-474-01 IC MSM514400E-60TS-K

HCD-GNX660
CDG
Ref. No.
IC1003
IC1005
IC1006

Part No.

Description

Remarks

6-703-547-01 IC TA7805LS
8-759-584-98 IC SN74AHCT04NSR
6-703-378-01 IC NJM2575F1-TE2
< JACK >

J1001

Part No.

1-216-296-11 SHORT CHIP

1-216-296-11 SHORT CHIP

Description

Remarks

C737

1-164-159-21 CERAMIC

0.1uF

C741
C751
C752

1-162-306-11 CERAMIC
1-162-306-11 CERAMIC
1-164-159-21 CERAMIC

0.01uF
0.01uF
0.1uF

50V
20%
20%

16V
16V
50V

< CONNECTOR >

1-794-970-11 JACK, PIN 1P (VIDEO OUT)

CN701
CN702
* CN703
CN704

< COIL >

L1001
L1002

Ref. No.

IR

DRIVER

0
0

1-784-735-11
1-784-766-11
1-564-720-11
1-785-328-11

CONNECTOR, FFC 13P

CONNECTOR, FFC 5P
PIN, CONNECTOR (SMALL TYPE) 4P
PIN, CONNECTOR (LIGHT ANGRE) 2P
< DIODE >

< TRANSISTOR >

Q1001
Q1002
Q1004
Q1005
Q1006

8-729-027-43
8-729-027-43
8-729-027-43
8-729-027-43
8-729-027-23

TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR

DTC114EKA-T146
DTC114EKA-T146
DTC114EKA-T146
DTC114EKA-T146
DTA114EKA-T146

Q1007
Q1008
Q1009
Q1010

8-729-027-43
8-729-140-04
8-729-027-23
8-729-027-43

TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR

DTC114EKA-T146
2SB1116A-L
DTA114EKA-T146
DTC114EKA-T146

D701
D711

8-719-921-42 DIODE MTZJ-5.1A

8-719-109-69 DIODE RD3.6ESB2
< IC >

IC701
IC712

8-759-598-69 IC BA6956AN
8-759-598-69 IC BA6956AN
< TRANSISTOR >

Q731

8-729-029-66 TRANSISTOR DTC114ESA

< RESISTOR >

< RESISTOR >
R1003
R1004
R1005
R1006
R1011

1-216-829-11
1-216-825-11
1-216-825-11
1-216-829-11
1-216-825-11

METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP

4.7K
2.2K
2.2K
4.7K
2.2K

5%
5%
5%
5%
5%

1/10W
1/10W
1/10W
1/10W
1/10W

R1012
R1013
R1015
R1016
R1017

1-216-829-11
1-216-820-11
1-216-864-11
1-216-833-11
1-216-833-11

METAL CHIP
METAL CHIP
SHORT CHIP
METAL CHIP
METAL CHIP

4.7K
820
0
10K
10K

5%
5%

1/10W
1/10W

5%
5%

1/10W
1/10W

R1018
R1019
R1020
R1021
R1022

1-216-833-11
1-216-833-11
1-216-833-11
1-216-813-11
1-216-813-11

METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP

10K
10K
10K
220
220

5%
5%
5%
5%
5%

1/10W
1/10W
1/10W
1/10W
1/10W

R1023
R1029
R1030
R1031
R1032

1-216-813-11
1-216-809-11
1-216-837-11
1-218-285-11
1-216-833-11

METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP

220
100
22K
75
10K

5%
5%
5%
5%
5%

1/10W
1/10W
1/10W
1/10W
1/10W

R1033
R1034

1-216-829-11 METAL CHIP

1-216-829-11 METAL CHIP

4.7K
4.7K

5%
5%

1/10W
1/10W

R701
R702
R711
R712
R713

1-249-413-11
1-247-807-31
1-249-417-11
1-249-425-11
1-249-433-11

CARBON
CARBON
CARBON
CARBON
CARBON

470
100
1K
4.7K
22K

5%
5%
5%
5%
5%

1/4W
1/4W
1/4W
1/4W
1/4W

R721
R722
R723
R731
R732

1-249-425-11
1-249-425-11
1-249-425-11
1-247-807-31
1-249-429-11

CARBON
CARBON
CARBON
CARBON
CARBON

4.7K
4.7K
4.7K
100
10K

5%
5%
5%
5%
5%

1/4W
1/4W
1/4W
1/4W
1/4W

R733
1-249-417-11 CARBON
1K
5%
1/4W
R734
1-249-430-11 CARBON
12K
5%
1/4W
R736
1-249-412-11 CARBON
390
5%
1/4W
R751
1-249-425-11 CARBON
4.7K
5%
1/4W
************************************************************
IR BOARD
********
< CAPACITOR >
C1308

1-115-416-11 CERAMIC CHIP

0.001uF

5%

25V

< CONNECTOR >

< VIBRATOR >
CN1403 1-816-423-11 SOCKET, CONNECTOR 3P
X1002 1-781-821-21 VIBRATOR, CRYSTAL (14.31818MHz)
************************************************************

< IC >
IC1301

A-1103-756-B DRIVER BOARD, COMPLETE

***********************

6-600-309-01 IC RPM7240-H9 ( g )
< RESISTOR >

< CAPACITOR >

C715
C731
C735
C736

1-126-933-11
1-126-964-11
1-164-159-21
1-164-159-21

ELECT
ELECT
CERAMIC
CERAMIC

100uF
10uF
0.1uF
0.1uF

20%
20%

16V
50V
50V
50V

R1306 1-216-805-11 METAL CHIP

47
5%
1/10W
************************************************************

71

HCD-GNX660
Ver. 1.2
MAIN
Ref. No.

Part No.

Description

Remarks

A-1159-558-A MAIN BOARD, COMPLETE

*********************

Ref. No.

Part No.

Description

Remarks

C162
C163
C164

1-162-969-11 CERAMIC CHIP

1-126-964-11 ELECT
1-137-196-11 FILM

0.0068uF 10%
10uF
20%
0.68uF
5%

25V (-13)
50V
50V

C165
C166
C168
C169
C170

1-137-195-11
1-126-963-11
1-162-962-11
1-126-964-11
1-162-970-11

FILM
ELECT
CERAMIC CHIP
ELECT
CERAMIC CHIP

0.56uF
4.7uF
470PF
10uF
0.01uF

5%
20%
10%
20%
10%

50V
50V
50V
50V
25V

C171
C172
C173
C174
C175

1-126-960-11
1-126-964-11
1-162-957-11
1-162-928-11
1-162-959-11

ELECT
ELECT
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP

1uF
10uF
220PF
120PF
330PF

20%
20%
5%
5%
5%

50V
50V
50V
50V
50V

C176
C177
C178
C179
C180

1-162-964-11
1-137-194-81
1-162-970-11
1-162-970-11
1-164-172-11

CERAMIC CHIP
FILM
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP

0.001uF
0.47uF
0.01uF
0.01uF
0.0056uF

10%
5%
10%
10%
10%

50V
50V
25V
25V
25V

C184
C185
C186
C187
C188

1-162-927-11
1-162-927-11
1-110-563-11
1-104-658-91
1-163-077-00

CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
ELECT
CERAMIC CHIP

100PF
100PF
0.068uF
100uF
0.1uF

5%
5%
10%
20%
10%

50V
50V
16V
10V
25V

C189
C190
C191
C192
C193

1-162-957-11
1-162-957-11
1-137-189-11
1-126-960-11
1-137-189-11

CERAMIC CHIP
CERAMIC CHIP
FILM
ELECT
FILM

220PF
220PF
0.18uF
1uF
0.18uF

5%
5%
5%
20%
5%

50V
50V
50V
50V
50V

C194
C195
C197
C198
C199

1-126-964-11
1-126-960-11
1-162-968-11
1-126-961-11
1-162-966-11

ELECT
ELECT
CERAMIC CHIP
ELECT
CERAMIC CHIP

10uF
1uF
0.0047uF
2.2uF
0.0022uF

20%
20%
10%
20%
10%

50V
50V
50V
50V
50V

C200
C201
C202
C203
C204

1-162-966-11
1-162-953-11
1-162-970-11
1-162-953-11
1-162-953-11

CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP

0.0022uF
100PF
0.01uF
100PF
100PF

10%
5%
10%
5%
5%

50V
50V
25V
50V
50V

C213
C214
C215
C216
C226

1-136-497-81
1-136-497-81
1-126-964-11
1-136-497-81
1-162-953-11

FILM
FILM
ELECT
FILM
CERAMIC CHIP

0.1uF
0.1uF
10uF
0.1uF
100PF

5%
5%
20%
5%
5%

50V
50V
50V
50V
50V

C228
C230
C238
C267
C288

1-162-953-11
1-126-961-11
1-126-964-11
1-126-964-11
1-126-964-11

CERAMIC CHIP
ELECT
ELECT
ELECT
ELECT

100PF
2.2uF
10uF
10uF
10uF

5%
20%
20%
20%
20%

50V
50V
50V
50V
50V

C301
C302
C303
C304
C307

1-126-965-91
1-126-965-91
1-126-961-11
1-126-961-11
1-126-961-11

ELECT
ELECT
ELECT
ELECT
ELECT

22uF
22uF
2.2uF
2.2uF
2.2uF

20%
20%
20%
20%
20%

50V
50V
50V
50V
50V

C308
C410
C411
C412
C414

1-126-961-11
1-162-919-11
1-162-918-11
1-164-156-11
1-164-156-11

ELECT
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP

2.2uF
22PF
18PF
0.1uF
0.1uF

20%
5%
5%

50V
50V
50V
25V
25V

7-685-646-79 SCREW +BVTP 3X8 TYPE2 TT (B)

< CAPACITOR >
C101
C103
C104
C105
C106

1-126-964-11
1-126-964-11
1-126-964-11
1-126-964-11
1-115-412-11

ELECT
ELECT
ELECT
ELECT
CERAMIC CHIP

10uF
10uF
10uF
10uF
680PF

20%
20%
20%
20%
5%

50V
50V
50V
50V
25V

C107
C108
C109
C110
C111

1-136-497-81
1-104-700-11
1-104-700-11
1-126-964-11
1-100-436-91

FILM
CERAMIC CHIP
CERAMIC CHIP
ELECT
CERAMIC CHIP

0.1uF
0.027uF
0.027uF
10uF
0.033uF

5%
10%
10%
20%
10%

50V
16V
16V
50V
25V

C112
C112
C113
C114
C115

1-162-968-11
1-162-969-11
1-126-964-11
1-136-175-00
1-137-195-11

CERAMIC CHIP
CERAMIC CHIP
ELECT
FILM
FILM

0.0047uF
0.0068uF
10uF
0.68uF
0.56uF

10%
10%
20%
5%
5%

50V (-12)
25V (-13)
50V
50V
50V

C116
C118
C119
C120
C121

1-126-963-11
1-162-962-11
1-126-964-11
1-162-970-11
1-126-960-11

ELECT
CERAMIC CHIP
ELECT
CERAMIC CHIP
ELECT

4.7uF
470PF
10uF
0.01uF
1uF

20%
10%
20%
10%
20%

50V
50V
50V
25V
50V

C122
C123
C124
C125
C126

1-126-964-11
1-162-957-11
1-162-928-11
1-162-959-11
1-162-964-11

ELECT
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP

10uF
220PF
120PF
330PF
0.001uF

20%
5%
5%
5%
10%

50V
50V
50V
50V
50V

C130
C132
C133
C134
C135

1-164-172-11
1-126-933-11
1-126-960-11
1-162-927-11
1-162-927-11

CERAMIC CHIP
ELECT
ELECT
CERAMIC CHIP
CERAMIC CHIP

0.0056uF
100uF
1uF
100PF
100PF

10%
20%
20%
5%
5%

25V
16V
50V
50V
50V

C136
C137
C138
C139
C140

1-126-933-11
1-126-925-91
1-162-968-11
1-137-150-11
1-126-947-11

ELECT
ELECT
CERAMIC CHIP
FILM
ELECT

100uF
470uF
0.0047uF
0.01uF
47uF

20%
20%
10%
5%
20%

16V
10V
50V
100V
35V

C141
C142
C144
C145
C147

1-162-970-11
1-130-481-00
1-162-968-11
1-162-968-11
1-162-968-11

CERAMIC CHIP
MYLAR
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP

0.01uF
0.0068uF
0.0047uF
0.0047uF
0.0047uF

10%
5%
10%
10%
10%

25V
50V
50V
50V
50V

C148
C150
C151
C153
C154

1-126-961-11
1-126-964-11
1-126-964-11
1-126-964-11
1-126-964-11

ELECT
ELECT
ELECT
ELECT
ELECT

2.2uF
10uF
10uF
10uF
10uF

20%
20%
20%
20%
20%

50V
50V
50V
50V
50V

C156
C157
C158
C159
C160

1-115-412-11
1-136-497-81
1-104-700-11
1-104-700-11
1-126-964-11

CERAMIC CHIP
FILM
CERAMIC CHIP
CERAMIC CHIP
ELECT

680PF
0.1uF
0.027uF
0.027uF
10uF

5%
5%
10%
10%
20%

25V
50V
16V
16V
50V

C161
C162

1-100-436-91 CERAMIC CHIP

1-162-968-11 CERAMIC CHIP

72

0.033uF 10%
0.0047uF 10%

25V
50V (-12)

HCD-GNX660
Ver. 1.2
MAIN
Ref. No.

Part No.

Description

C416
C462
C464
C486
C496

1-126-917-11
1-104-658-91
1-164-156-11
1-104-655-91
1-126-964-11

ELECT
ELECT
CERAMIC CHIP
ELECT
ELECT

3300uF
100uF
0.1uF
470uF
10uF

20%
20%

C497
C498
C499
C504
C504

1-126-960-11
1-164-156-11
1-164-156-11
1-126-925-91
1-126-926-11

ELECT
CERAMIC CHIP
CERAMIC CHIP
ELECT
ELECT

1uF
0.1uF
0.1uF
470uF
1000uF

20%

C520
C521
C522
C523
C526

1-126-964-11
1-162-960-11
1-162-960-11
1-162-960-11
1-164-156-11

ELECT
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP

10uF
220PF
220PF
220PF
0.1uF

20%
10%
10%
10%

C527
C531
C533
C534
C535

1-162-960-11
1-164-156-11
1-126-926-11
1-164-156-11
1-126-926-11

CERAMIC CHIP
CERAMIC CHIP
ELECT
CERAMIC CHIP
ELECT

220PF
0.1uF
1000uF
0.1uF
1000uF

10%

C536
C537
C538
C539
C546

1-164-156-11
1-164-156-11
1-164-156-11
1-164-156-11
1-162-960-11

CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP

C547
C550
C551
C552
C553

1-162-960-11
1-126-937-11
1-126-960-11
1-126-925-91
1-126-960-11

C554
C555
C556
C567
C568

20%
20%

20%
20%

Remarks

Ref. No.

Part No.

6.3V
10V
25V
6.3V
50V

* CN590

1-564-510-11 PLUG, CONNECTOR 7P

50V (-13)
25V
25V
10V (-13)
10V (-12)
50V
50V
50V
50V
25V

Description

< DIODE >

D101
D102
D104
D213
D214

6-501-193-01
6-501-193-01
6-501-193-01
6-501-193-01
6-501-193-01

DIODE
DIODE
DIODE
DIODE
DIODE

1SS355WTE-17
1SS355WTE-17
1SS355WTE-17
1SS355WTE-17
1SS355WTE-17

D215
D216
D230
D231
D232

6-501-193-01
6-501-193-01
6-501-193-01
6-501-193-01
6-501-193-01

DIODE
DIODE
DIODE
DIODE
DIODE

1SS355WTE-17
1SS355WTE-17
1SS355WTE-17
1SS355WTE-17
1SS355WTE-17

D393
D394
D395
D396
D486

6-501-193-01
6-501-193-01
6-501-193-01
6-501-193-01
6-501-193-01

DIODE
DIODE
DIODE
DIODE
DIODE

1SS355WTE-17
1SS355WTE-17
1SS355WTE-17
1SS355WTE-17
1SS355WTE-17

D506
D561
D562
D563
D580

6-501-193-01
6-500-522-21
6-500-522-21
6-500-522-21
6-501-193-01

DIODE
DIODE
DIODE
DIODE
DIODE

1SS355WTE-17
10EDB40-TB3
10EDB40-TB3
10EDB40-TB3
1SS355WTE-17

D581
D582
D583
D586
D594

8-719-069-56
6-501-193-01
8-719-978-33
6-500-522-21
6-500-522-21

DIODE
DIODE
DIODE
DIODE
DIODE

UDZSTE-176.2B
1SS355WTE-17
DTZ-TT11-6.8B
10EDB40-TB3
10EDB40-TB3

20%

50V
25V
10V
25V
10V

0.1uF
0.1uF
0.1uF
0.1uF
220PF

10%

25V
25V
25V
25V
50V

CERAMIC CHIP
ELECT
ELECT
ELECT
ELECT

220PF
4700uF
1uF
470uF
1uF

10%
20%
20%
20%
20%

50V
16V
50V
10V
50V

1-126-925-91
1-107-826-11
1-107-826-11
1-107-826-11
1-126-916-11

ELECT
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
ELECT

470uF
0.1uF
0.1uF
0.1uF
1000uF

20%
10%
10%
10%
20%

10V
16V
16V
16V
6.3V

FB101
FB102
FB103
FB104
FB151

1-216-864-11
1-469-125-21
1-216-864-11
1-469-125-21
1-216-864-11

SHORT CHIP
0
FERRITE, EMI (SMD) (1608)
SHORT CHIP
0
FERRITE, EMI (SMD) (1608)
SHORT CHIP
0

C570
C571
C580
C581
C582

1-126-964-11
1-162-960-11
1-164-156-11
1-164-156-11
1-126-937-11

ELECT
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
ELECT

10uF
220PF
0.1uF
0.1uF
4700uF

20%
10%

50V
50V
25V
25V
16V

FB152
FB153
FB505
FB506
FB507

1-469-125-21
1-216-864-11
1-216-864-11
1-500-283-11
1-500-283-11

FERRITE, EMI (SMD) (1608)

SHORT CHIP
0
SHORT CHIP
0
INDUCTOR, FERRITE BEAD
INDUCTOR, FERRITE BEAD

C583
C585

1-126-963-11 ELECT
1-164-156-11 CERAMIC CHIP

4.7uF
0.1uF

20%

50V
25V

FB508
FB509
FB510
FB512
FB513

1-500-283-11
1-500-283-11
1-500-283-11
1-500-283-11
1-414-235-22

INDUCTOR, FERRITE BEAD

INDUCTOR, FERRITE BEAD
INDUCTOR, FERRITE BEAD
INDUCTOR, FERRITE BEAD
INDUCTOR, FERRITE BEAD

FB514
FB555

1-414-235-22 INDUCTOR, FERRITE BEAD

1-216-864-11 SHORT CHIP
0

20%

20%

< CONNECTOR >

Remarks

< FERRITE BEAD >

CN101
CN105
* CN111
CN121
* CN131

1-784-772-11
1-784-780-11
1-568-449-11
1-564-705-11
1-564-710-11

CONNECTOR, FFC 11P

CONNECTOR, FFC 19P
HOUSING, CONNECTOR (PC BOARD) 3P
PIN, CONNECTOR (SMALL TYPE) 3P
PIN, CONNECTOR (SMALL TYPE) 8P

CN201
CN205
* CN321
CN351
* CN381

1-784-786-11
1-785-317-11
1-784-774-11
1-779-299-11
1-766-718-21

CONNECTOR, FFC 25P

PIN, CONNECTOR (STRAIGHT) 5P
CONNECTOR, FFC 13P
CONNECTOR, FFC (LIF (NON-ZIF)) 31P
CONNECTOR, BOARD TO BOARD 17P

IC101
IC401
IC402
IC403
IC551

6-705-667-01
6-807-073-01
6-701-680-01
6-707-095-01
6-703-550-01

CN402
CN405
CN406
CN580

1-785-336-11
1-784-774-11
1-568-828-11
1-564-506-11

PIN, CONNECTOR (LIGHT ANGLE) 10P

CONNECTOR, FFC 13P
CONNECTOR, FFC 9P
PLUG, CONNECTOR 3P

IC552
IC562

6-703-550-01 IC TA7809LS
6-703-546-01 IC TA7804LS

< IC >
IC
IC
IC
IC
IC

M61537FP-RF0G
M30622MGP-A54FPU0
PST3629NR
BH2210FV-E2
TA7809LS

73

HCD-GNX660
Ver. 1.2
MAIN
Ref. No.

Part No.

Description

Remarks

< JACK >

J501
J506

1-815-045-11 JACK, PIN 2P (AUDIO IN)

1-820-048-11 CONNECTOR (LIGHTING) (D-LIGHT SYNC OUT)
< JUMPER RESISTOR >

JR001
JR002
JR003
JR004
JR005

1-216-296-11
1-216-864-11
1-216-864-11
1-216-864-11
1-216-864-11

SHORT CHIP
SHORT CHIP
SHORT CHIP
SHORT CHIP
SHORT CHIP

0
0
0
0
0

JR006
JR007
JR008
JR009
JR011

1-216-864-11
1-216-864-11
1-216-864-11
1-216-864-11
1-216-864-11

SHORT CHIP
SHORT CHIP
SHORT CHIP
SHORT CHIP
SHORT CHIP

0
0
0
0
0

JR012
JR013
JR014
JR015
JR016

1-216-864-11
1-216-296-11
1-216-296-11
1-216-864-11
1-216-864-11

SHORT CHIP
SHORT CHIP
SHORT CHIP
SHORT CHIP
SHORT CHIP

0
0
0
0
0

JR017
JR018
JR019
JR020
JR021

1-216-864-11
1-216-864-11
1-216-864-11
1-216-864-11
1-216-296-11

SHORT CHIP
SHORT CHIP
SHORT CHIP
SHORT CHIP
SHORT CHIP

0
0
0
0
0

JR022
JR024
JR026
JR027
JR028

1-216-864-11
1-216-296-11
1-216-864-11
1-216-864-11
1-216-864-11

SHORT CHIP
SHORT CHIP
SHORT CHIP
SHORT CHIP
SHORT CHIP

0
0
0
0
0

JR029
JR030
JR031
JR032
JR033

1-216-864-11
1-216-864-11
1-216-864-11
1-216-864-11
1-216-864-11

SHORT CHIP
SHORT CHIP
SHORT CHIP
SHORT CHIP
SHORT CHIP

0
0
0
0
0

JR036
JR037
JR042
JR043
JR044

1-216-864-11
1-216-864-11
1-216-864-11
1-216-864-11
1-216-864-11

SHORT CHIP
SHORT CHIP
SHORT CHIP
SHORT CHIP
SHORT CHIP

0
0
0
0
0

JR046
JR047
JR048
JR049
JR050

1-216-864-11
1-216-864-11
1-216-296-11
1-216-864-11
1-216-864-11

SHORT CHIP
SHORT CHIP
SHORT CHIP
SHORT CHIP
SHORT CHIP

0
0
0
0
0

JR051
JR056
JR057
JR059
JR126

1-216-864-11
1-216-296-11
1-216-296-11
1-216-296-11
1-216-864-11

SHORT CHIP
SHORT CHIP
SHORT CHIP
SHORT CHIP
SHORT CHIP

0
0
0
0
0

JR152
JR153
JR176
JR228
JR261

1-216-296-11
1-216-296-11
1-216-864-11
1-216-864-11
1-216-864-11

SHORT CHIP
SHORT CHIP
SHORT CHIP
SHORT CHIP
SHORT CHIP

0
0
0
0
0

JR267
JR318

1-216-864-11 SHORT CHIP

1-216-864-11 SHORT CHIP

0
0

74

Ref. No.

Part No.

Description

Remarks

JR381
JR467
JR480

1-216-864-11 SHORT CHIP

1-216-864-11 SHORT CHIP
1-216-864-11 SHORT CHIP

0
0
0

JR481
JR487
JR550
JR555

1-216-864-11
1-216-864-11
1-216-864-11
1-216-864-11

0
0
0
0

SHORT CHIP
SHORT CHIP
SHORT CHIP
SHORT CHIP
< COIL >

L103
L104
L105

1-410-780-11 INDUCTOR
1-410-780-11 INDUCTOR
1-414-189-31 INDUCTOR

27mH
27mH
100uH

< TRANSISTOR >

Q101
Q103
Q104
Q105
Q106

8-729-901-81
8-729-802-80
8-729-802-80
8-729-802-80
8-729-802-80

TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR

2SC2412K-T-146-R
2SC3661
2SC3661
2SC3661
2SC3661

Q107
Q108
Q109
Q110
Q111

8-729-216-22
8-729-027-43
8-729-027-43
8-729-027-23
8-729-027-43

TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR

2SA1162-G
DTC114EKA-T146
DTC114EKA-T146
DTA114EKA-T146
DTC114EKA-T146

Q112
Q113
Q114
Q118
Q119

8-729-141-75
6-550-185-01
8-729-027-43
8-729-903-46
8-729-027-43

TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR

2SD596DV345
RT1P137P-TP-1
DTC114EKA-T146
2SB1132-P
DTC114EKA-T146

Q120
Q121
Q122
Q123
Q125

8-729-903-46
8-729-027-43
8-729-903-46
8-729-027-43
8-729-802-80

TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR

2SB1132-P
DTC114EKA-T146
2SB1132-P
DTC114EKA-T146
2SC3661

Q151
Q153
Q154
Q155
Q156

8-729-901-81
8-729-802-80
8-729-802-80
8-729-802-80
8-729-230-49

TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR

2SC2412K-T-146-R
2SC3661
2SC3661
2SC3661
2SC2712-YG (-13)

Q157
Q166
Q175
Q213
Q237

8-729-230-49
8-729-802-80
8-729-802-80
8-729-901-00
8-729-802-80

TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR

2SC2712-YG (-13)
2SC3661
2SC3661
DTC124EK
2SC3661

Q287
Q301
Q302
Q303
Q304

8-729-802-80
8-729-027-31
8-729-027-43
8-729-027-31
8-729-027-43

TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR

2SC3661
DTA124EKA-T146
DTC114EKA-T146
DTA124EKA-T146
DTC114EKA-T146

Q307
Q308
Q486
Q560
Q561

8-729-027-31
8-729-027-43
8-729-027-43
6-550-185-01
8-729-027-43

TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR

DTA124EKA-T146
DTC114EKA-T146
DTC114EKA-T146
RT1P137P-TP-1
DTC114EKA-T146

Q580
Q582
Q584
Q585

8-729-901-81
8-729-901-81
8-729-027-43
8-729-026-68

TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR

2SC2412K-T-146-R
2SC2412K-T-146-R
DTC114EKA-T146
2SD2525 (TP)

HCD-GNX660
MAIN
Ref. No.

Part No.

Description

Remarks

< RESISTOR >

R101
R102
R103
R104
R105

1-216-812-11
1-216-825-11
1-216-833-11
1-216-841-11
1-216-841-11

METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP

180
2.2K
10K
47K
47K

5%
5%
5%
5%
5%

1/10W
1/10W
1/10W
1/10W
1/10W

R106
R107
R108
R109
R110

1-216-830-11
1-216-829-11
1-216-825-11
1-216-836-11
1-216-851-11

METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP

5.6K
4.7K
2.2K
18K
330K

5%
5%
5%
5%
5%

1/10W
1/10W
1/10W
1/10W
1/10W

R111
R112
R113
R114
R115

1-216-821-11
1-216-833-11
1-216-833-11
1-216-864-11
1-216-833-11

METAL CHIP
METAL CHIP
METAL CHIP
SHORT CHIP
METAL CHIP

1K
10K
10K
0
10K

5%
5%
5%

1/10W
1/10W
1/10W

5%

1/10W

R116
R117
R118
R119
R120

1-216-833-11
1-216-825-11
1-216-835-11
1-216-817-11
1-216-829-11

METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP

10K
2.2K
15K
470
4.7K

5%
5%
5%
5%
5%

1/10W
1/10W
1/10W
1/10W
1/10W

R121
R122
R123
R124
R125

1-216-827-11
1-216-825-11
1-216-825-11
1-216-825-11
1-216-838-11

METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP

3.3K
2.2K
2.2K
2.2K
27K

5%
5%
5%
5%
5%

1/10W
1/10W
1/10W
1/10W
1/10W

R126
R127
R128
R129
R130

1-216-829-11
1-216-830-11
1-216-837-11
1-216-829-11
1-216-841-11

METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP

4.7K
5.6K
22K
4.7K
47K

5%
5%
5%
5%
5%

1/10W
1/10W
1/10W
1/10W
1/10W

R131
R133
R138
R139
R140

1-216-827-11
1-216-857-11
1-216-841-11
1-216-864-11
1-216-833-11

METAL CHIP
METAL CHIP
METAL CHIP
SHORT CHIP
METAL CHIP

3.3K
1M
47K
0
10K

5%
5%
5%

1/10W
1/10W
1/10W

5%

1/10W

R141
R142
R143
R144
R145

1-216-833-11
1-216-833-11
1-216-827-11
1-216-805-11
1-216-833-11

METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP

10K
10K
3.3K
47
10K

5%
5%
5%
5%
5%

1/10W
1/10W
1/10W
1/10W
1/10W

R146
R147
R148
R149
R150

1-216-797-11
1-216-803-11
1-216-841-11
1-216-829-11
1-216-841-11

METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP

10
33
47K
4.7K
47K

5%
5%
5%
5%
5%

1/10W
1/10W
1/10W
1/10W
1/10W

R151
R152
R153
R155
R156

1-216-812-11
1-216-825-11
1-216-833-11
1-216-841-11
1-216-830-11

METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP

180
2.2K
10K
47K
5.6K

5%
5%
5%
5%
5%

1/10W
1/10W
1/10W
1/10W
1/10W

R157
R158
R159
R160
R161

1-216-836-11
1-216-825-11
1-469-125-21
1-216-851-11
1-216-821-11

METAL CHIP
18K
METAL CHIP
2.2K
FERRITE, EMI (SMD) (1608)
METAL CHIP
330K
METAL CHIP
1K

5%
5%

1/10W
1/10W

5%
5%

1/10W
1/10W

R162

1-216-833-11 METAL CHIP

5%

1/10W

10K

Ref. No.

Part No.

Description

Remarks

R163
R164
R165
R166

1-216-833-11
1-216-864-11
1-469-125-21
1-216-833-11

METAL CHIP
10K
5%
SHORT CHIP
0
FERRITE, EMI (SMD) (1608)
METAL CHIP
10K
5%

1/10W

R167
R168
R169
R172
R173

1-216-825-11
1-216-835-11
1-216-817-11
1-216-825-11
1-216-825-11

METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP

2.2K
15K
470
2.2K
2.2K

5%
5%
5%
5%
5%

1/10W
1/10W
1/10W
1/10W
1/10W

R174
R175
R176
R177
R178

1-216-825-11
1-216-838-11
1-216-829-11
1-216-830-11
1-216-819-11

METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP

2.2K
27K
4.7K
5.6K
680

5%
5%
5%
5%
5%

1/10W
1/10W
1/10W
1/10W
1/10W

R179
R180
R181
R182
R183

1-216-825-11
1-216-825-11
1-216-819-11
1-216-827-11
1-216-827-11

METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP

2.2K
2.2K
680
3.3K
3.3K

5%
5%
5%
5%
5%

1/10W
1/10W
1/10W
1/10W
1/10W

R184
R186
R188
R189
R190

1-216-827-11
1-216-825-11
1-216-841-11
1-216-864-11
1-216-833-11

METAL CHIP
METAL CHIP
METAL CHIP
SHORT CHIP
METAL CHIP

3.3K
2.2K
47K
0
10K

5%
5%
5%

1/10W
1/10W
1/10W

5%

1/10W

R191
R192
R193
R194
R195

1-216-817-11
1-216-817-11
1-216-829-11
1-216-829-11
1-216-857-11

METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP

470
470
4.7K
4.7K
1M

5%
5%
5%
5%
5%

1/10W
1/10W
1/10W
1/10W
1/10W

R196
R197
R198
R199
R200

1-216-825-11
1-216-819-11
1-469-125-21
1-469-125-21
1-216-841-11

METAL CHIP
2.2K
5%
METAL CHIP
680
5%
FERRITE, EMI (SMD) (1608)
FERRITE, EMI (SMD) (1608)
METAL CHIP
47K
5%

1/10W
1/10W

1/10W

R202
R203
R204
R205
R207

1-216-809-11
1-216-809-11
1-216-809-11
1-216-809-11
1-216-809-11

METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP

100
100
100
100
100

5%
5%
5%
5%
5%

1/10W
1/10W
1/10W
1/10W
1/10W

R209
R210
R212
R214
R215

1-216-809-11
1-216-809-11
1-216-809-11
1-216-864-11
1-216-821-11

METAL CHIP
METAL CHIP
METAL CHIP
SHORT CHIP
METAL CHIP

100
100
100
0
1K

5%
5%
5%

1/10W
1/10W
1/10W

5%

1/10W

R216
R220
R221
R222
R224

1-216-813-11
1-216-809-11
1-216-809-11
1-216-809-11
1-216-809-11

METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP

220
100
100
100
100

5%
5%
5%
5%
5%

1/10W
1/10W
1/10W
1/10W
1/10W

R225
R226
R227
R230
R231

1-216-839-11
1-216-809-11
1-216-864-11
1-216-809-11
1-216-841-11

METAL CHIP
METAL CHIP
SHORT CHIP
METAL CHIP
METAL CHIP

33K
100
0
100
47K

5%
5%

1/10W
1/10W

5%
5%

1/10W
1/10W

R244
R245
R246
R267

1-216-825-11
1-216-841-11
1-216-833-11
1-216-864-11

METAL CHIP
METAL CHIP
METAL CHIP
SHORT CHIP

2.2K
47K
10K
0

5%
5%
5%

1/10W
1/10W
1/10W

1/10W

75

HCD-GNX660
Ver. 1.2
MAIN
Ref. No.

Part No.

Description

Remarks

R294

1-216-825-11 METAL CHIP

2.2K

5%

1/10W

R295
R296
R301
R302
R303

1-216-841-11
1-216-833-11
1-216-833-11
1-216-837-11
1-216-845-11

METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP

47K
10K
10K
22K
100K

5%
5%
5%
5%
5%

1/10W
1/10W
1/10W
1/10W
1/10W

R304
R305
R306
R308
R309

1-216-835-11
1-216-843-11
1-216-829-11
1-216-853-11
1-216-833-11

METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP

15K
68K
4.7K
470K
10K

5%
5%
5%
5%
5%

1/10W
1/10W
1/10W
1/10W
1/10W

R310
R311
R312
R329
R330

1-216-835-11
1-216-843-11
1-216-853-11
1-216-833-11
1-216-833-11

METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP

15K
68K
470K
10K
10K

5%
5%
5%
5%
5%

1/10W
1/10W
1/10W
1/10W
1/10W

R337
R338
R340
R341
R354

1-216-833-11
1-216-833-11
1-216-833-11
1-216-833-11
1-216-833-11

METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP

10K
10K
10K
10K
10K

5%
5%
5%
5%
5%

1/10W
1/10W
1/10W
1/10W
1/10W

R355
R372
R373
R374
R385

1-216-833-11
1-216-833-11
1-216-833-11
1-216-833-11
1-216-833-11

METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP

10K
10K
10K
10K
10K

5%
5%
5%
5%
5%

1/10W
1/10W
1/10W
1/10W
1/10W

R392
R393
R394
R395
R397

1-216-829-11
1-216-821-11
1-216-827-11
1-216-827-11
1-216-827-11

METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP

4.7K
1K
3.3K
3.3K
3.3K

5%
5%
5%
5%
5%

1/10W
1/10W
1/10W
1/10W
1/10W

R398

1-216-849-11 METAL CHIP

220K

5%

R399

1-216-845-11 METAL CHIP

100K

5%

R401
R402
R403

1-216-809-11 METAL CHIP

1-216-809-11 METAL CHIP
1-216-809-11 METAL CHIP

100
100
100

5%
5%
5%

1/10W
(-13)
1/10W
(-13)
1/10W
1/10W
1/10W

R404
R405
R406
R407
R411

1-216-809-11
1-216-809-11
1-216-809-11
1-216-809-11
1-216-851-11

METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP

100
100
100
100
330K

5%
5%
5%
5%
5%

1/10W
1/10W
1/10W
1/10W
1/10W

R412
R413
R417
R419
R420

1-216-845-11
1-216-864-11
1-216-833-11
1-216-809-11
1-216-821-11

METAL CHIP
SHORT CHIP
METAL CHIP
METAL CHIP
METAL CHIP

100K
0
10K
100
1K

5%

1/10W

5%
5%
5%

1/10W
1/10W
1/10W

R421
R422
R423
R424
R425

1-216-809-11
1-216-809-11
1-216-809-11
1-216-809-11
1-216-809-11

METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP

100
100
100
100
100

5%
5%
5%
5%
5%

1/10W
1/10W
1/10W
1/10W
1/10W

R426
R427
R428
R429
R430

1-216-809-11
1-216-809-11
1-216-809-11
1-216-809-11
1-216-809-11

METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP

100
100
100
100
100

5%
5%
5%
5%
5%

1/10W
1/10W
1/10W
1/10W
1/10W

76

Ref. No.

Part No.

Description

R431
R432
R433
R435
R436

1-216-809-11
1-216-809-11
1-216-809-11
1-216-809-11
1-216-809-11

METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP

100
100
100
100
100

5%
5%
5%
5%
5%

1/10W
1/10W
1/10W
1/10W
1/10W

R437
R438
R439
R440
R441

1-216-809-11
1-216-809-11
1-216-809-11
1-216-809-11
1-216-809-11

METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP

100
100
100
100
100

5%
5%
5%
5%
5%

1/10W
1/10W
1/10W
1/10W
1/10W

R442
R443
R444
R445
R446

1-216-809-11
1-216-809-11
1-216-809-11
1-216-809-11
1-216-809-11

METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP

100
100
100
100
100

5%
5%
5%
5%
5%

1/10W
1/10W
1/10W
1/10W
1/10W

R447
R448
R449
R450
R451

1-216-809-11
1-216-809-11
1-216-809-11
1-216-809-11
1-216-809-11

METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP

100
100
100
100
100

5%
5%
5%
5%
5%

1/10W
1/10W
1/10W
1/10W
1/10W

R452
R453
R454
R455
R456

1-216-809-11
1-216-809-11
1-216-809-11
1-216-809-11
1-216-812-11

METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP

100
100
100
100
180

5%
5%
5%
5%
5%

1/10W
1/10W
1/10W
1/10W
1/10W

R457
R458
R459
R460
R461

1-216-809-11
1-216-809-11
1-216-809-11
1-216-809-11
1-216-809-11

METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP

100
100
100
100
100

5%
5%
5%
5%
5%

1/10W
1/10W
1/10W
1/10W
1/10W

R463
R465
R472
R473
R474

1-216-809-11
1-216-809-11
1-216-809-11
1-216-809-11
1-216-809-11

METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP

100
100
100
100
100

5%
5%
5%
5%
5%

1/10W
1/10W
1/10W
1/10W
1/10W

R476
R477
R478
R479
R482

1-216-809-11
1-216-809-11
1-216-809-11
1-216-809-11
1-216-809-11

METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP

100
100
100
100
100

5%
5%
5%
5%
5%

1/10W
1/10W
1/10W
1/10W
1/10W

R483
R484
R485
R486
R488

1-216-809-11
1-216-809-11
1-216-809-11
1-216-825-11
1-216-825-11

METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP

100
100
100
2.2K
2.2K

5%
5%
5%
5%
5%

1/10W
1/10W
1/10W
1/10W
1/10W

R489
R490
R491
R492
R493

1-216-809-11
1-216-809-11
1-216-809-11
1-216-811-11
1-216-829-11

METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP

100
100
100
150
4.7K

5%
5%
5%
5%
5%

1/10W
1/10W
1/10W
1/10W
1/10W

R494
R495
R497
R500
R500

1-216-813-11
1-216-813-11
1-216-813-11
1-216-809-11
1-216-821-11

METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP

220
220
220
100
1K

5%
5%
5%
5%
5%

1/10W
1/10W
1/10W
1/10W (-12)
1/10W (-13)

4.7K
10
5.6K

5%
5%
5%

1/10W (-13)
1/4W
1/10W

R501
0 R506
R508

1-216-829-11 METAL CHIP

1-219-153-11 FUSIBLE
1-216-830-11 METAL CHIP

Remarks

HCD-GNX660
MAIN
Ref. No.

Part No.

Description

Remarks

Ref. No.

Part No.

Description

Ver. 1.2
MIC
Remarks

R509
R510

1-216-829-11 METAL CHIP

1-216-821-11 METAL CHIP

4.7K
1K

5%
5%

1/10W
1/10W

C1427
C1429

1-165-908-11 CERAMIC CHIP

1-124-463-00 ELECT

1uF
0.1uF

10%
20%

10V
50V

R511
R512
R513
R524
R525

1-216-821-11
1-216-821-11
1-216-821-11
1-216-821-11
1-216-845-11

METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP

1K
1K
1K
1K
100K

5%
5%
5%
5%
5%

1/10W
1/10W
1/10W
1/10W
1/10W

C1430
C1432
C1433
C1434
C1435

1-124-463-00
1-100-597-91
1-162-923-11
1-124-261-00
1-126-176-11

ELECT
CERAMIC CHIP
CERAMIC CHIP
ELECT
ELECT

0.1uF
0.1uF
47PF
10uF
220uF

20%
10%
5%
20%
20%

50V
25V (-13)
50V
50V
10V

R532
R560
R563
R574
R575

1-216-864-11
1-216-826-11
1-216-821-11
1-216-821-11
1-216-845-11

SHORT CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP

0
2.7K
1K
1K
100K

5%
5%
5%
5%

1/10W
1/10W
1/10W
1/10W

C1436
C1437
C1438
C1458
C1459

1-162-968-11
1-162-970-11
1-100-597-91
1-126-163-11
1-126-160-11

CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
ELECT
ELECT

0.0047uF
0.01uF
0.1uF
4.7uF
1uF

10%
10%
10%
20%
20%

50V
25V
25V (-13)
50V
50V

R576
R577
R578
R579
R580

1-216-841-11
1-216-845-11
1-216-829-11
1-216-827-11
1-216-827-11

METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP

47K
100K
4.7K
3.3K
3.3K

5%
5%
5%
5%
5%

1/10W
1/10W
1/10W
1/10W
1/10W

C1460
C1461
C1468
C1479
C1486

1-126-160-11
1-162-970-11
1-115-416-11
1-126-163-11
1-162-968-11

ELECT
CERAMIC CHIP
CERAMIC CHIP
ELECT
CERAMIC CHIP

1uF
0.01uF
0.001uF
4.7uF
0.0047uF

20%
10%
5%
20%
10%

50V
25V
25V
50V
50V

R582
R583
R584
R585
R586

1-216-864-11
1-216-827-11
1-216-830-11
1-216-841-11
1-216-830-11

SHORT CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP

0
3.3K
5.6K
47K
5.6K

C1487

1-162-970-11 CERAMIC CHIP

0.01uF

10%

25V

5%
5%
5%
5%

1/10W
1/10W
1/10W
1/10W

R587
R590
R591
R592
R593

1-216-841-11
1-216-833-11
1-216-833-11
1-216-845-11
1-216-845-11

METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP

47K
10K
10K
100K
100K

5%
5%
5%
5%
5%

1/10W
1/10W
1/10W
1/10W
1/10W

< DIODE >

D1400

8-719-069-54 DIODE UDZSTE-175.1B

< IC >

IC1400
IC1401

6-709-116-01 IC TC9488FG
8-759-710-97 IC NJM4565M-D
< JACK >

< TRANSFORMER >

T101

J1400
J1401
J1450

1-433-372-11 TRANSFORMER, BIAS OSCILLATION

1-817-629-11 JACK (LARGE TYPE) (MIC 1)

1-794-702-11 JACK, HEADPHONE (PHONES)
1-817-629-11 JACK (LARGE TYPE) (MIC 2)

< VIBRATOR >

< JUMPER RESISTOR >
X401
1-760-252-12 VIBRATOR, CRYSTAL (32.768kHz)
X402
1-795-058-21 VIBRATOR, CERAMIC (5MHz)
************************************************************
A-1167-713-A MIC BOARD, COMPLETE
********************
< CAPACITOR >
C1400
C1401
C1403
C1404
C1405

1-107-826-11
1-100-597-91
1-109-864-91
1-119-772-11
1-162-970-11

CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
ELECT
CERAMIC CHIP

0.1uF
0.1uF
68PF
47uF
0.01uF

10%
10%
2%
20%
10%

16V
25V
50V
35V
25V

C1406
C1407
C1408
C1409
C1410

1-124-589-11
1-124-589-11
1-126-163-11
1-126-160-11
1-126-160-11

ELECT
ELECT
ELECT
ELECT
ELECT

47uF
47uF
4.7uF
1uF
1uF

20%
20%
20%
20%
20%

16V
16V
50V
50V
50V

C1411
C1412
C1413
C1415
C1416

1-162-970-11
1-107-826-11
1-164-730-11
1-100-597-91
1-128-131-11

CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
ELECT

0.01uF
0.1uF
0.0012uF
0.1uF
22uF

10%
10%
10%
10%
20%

25V
16V
50V
25V
50V

C1418
C1419
C1424

1-164-392-11 CERAMIC CHIP

1-162-968-11 CERAMIC CHIP
1-100-597-91 CERAMIC CHIP

390PF
5%
0.0047uF 10%
0.1uF
10%

50V
50V
25V

JR1401
JR1403
JR1417
JR1427
JR1433

1-216-864-11
1-216-296-11
1-216-864-11
1-216-864-11
1-216-864-11

SHORT CHIP
SHORT CHIP
SHORT CHIP
SHORT CHIP
SHORT CHIP

0
0
0
0
0

JR1483 1-216-864-11 SHORT CHIP

< TRANSISTOR >

Q1400
Q1401
Q1450
Q1451

8-729-802-80
8-729-802-80
8-729-802-80
8-729-802-80

TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR

2SC3661
2SC3661
2SC3661
2SC3661

< RESISTOR >

R1401
R1402
R1403
R1404
R1405

1-216-829-11
1-216-809-11
1-216-809-11
1-216-809-11
1-216-815-11

METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP

4.7K
100
100
100
330

5%
5%
5%
5%
5%

1/10W
1/10W
1/10W
1/10W
1/10W

R1406
R1407
R1409
R1410
R1411

1-216-815-11
1-216-823-11
1-216-833-11
1-216-821-11
1-216-833-11

METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP

330
1.5K
10K
1K
10K

5%
5%
5%
5%
5%

1/10W
1/10W
1/10W
1/10W
1/10W

77

HCD-GNX660
Ver. 1.1
MIC
Ref. No.

MOTOR (LD)

MOTOR (TB)

PANEL

Part No.

Description

R1412
R1413
R1414
R1415
R1416

1-216-828-11
1-218-867-11
1-216-834-11
1-216-835-11
1-216-830-11

METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP

3.9K
6.8K
12K
15K
5.6K

5%
0.5%
5%
5%
5%

Remarks
1/10W
1/10W
1/10W
1/10W
1/10W

R1417
R1418
R1422
R1424
R1425

1-216-830-11
1-216-821-11
1-216-864-11
1-216-833-11
1-216-833-11

METAL CHIP
METAL CHIP
SHORT CHIP
METAL CHIP
METAL CHIP

5.6K
1K
0
10K
10K

5%
5%

1/10W
1/10W

5%
5%

1/10W
1/10W

R1426
R1427
R1431
R1432
R1433

1-216-842-11
1-216-837-11
1-216-864-11
1-216-797-11
1-216-797-11

METAL CHIP
METAL CHIP
SHORT CHIP
METAL CHIP
METAL CHIP

56K
22K
0
10
10

5%
5%

1/10W
1/10W

5%
5%

1/10W
1/10W

R1434
R1435
R1436
R1437
R1438

1-216-797-11
1-216-797-11
1-216-829-11
1-216-845-11
1-216-864-11

METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
SHORT CHIP

10
10
4.7K
100K
0

5%
5%
5%
5%

1/10W
1/10W
1/10W
1/10W

R1439
R1440
R1441
R1442
R1443

1-216-825-11
1-216-826-11
1-216-864-11
1-216-821-11
1-216-821-11

METAL CHIP
METAL CHIP
SHORT CHIP
METAL CHIP
METAL CHIP

2.2K
2.7K
0
1K
1K

5%
5%

1/10W
1/10W

5%
5%

1/10W
1/10W

R1457
R1459
R1460
R1461
R1476

1-216-823-11
1-216-833-11
1-216-821-11
1-216-833-11
1-216-837-11

METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP

1.5K
10K
1K
10K
22K

5%
5%
5%
5%
5%

1/10W
1/10W
1/10W
1/10W
1/10W

R1477
R1482
R1483
R1484
R1485

1-216-835-11
1-216-797-11
1-216-797-11
1-216-797-11
1-216-797-11

METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP

15K
10
10
10
10

5%
5%
5%
5%
5%

1/10W
1/10W
1/10W
1/10W
1/10W

R1486
R1492
R1493

1-216-829-11 METAL CHIP

1-216-821-11 METAL CHIP
1-216-821-11 METAL CHIP

4.7K
1K
1K

5%
5%
5%

1/10W
1/10W
1/10W

Ref. No.

Part No.

1-687-133-12 MOTOR (LD) BOARD

*****************
************************************************************
1-687-134-12 MOTOR (TB) BOARD
*****************

Remarks

C1300
C1301
C1302
C1304
C1305

1-126-965-91
1-162-995-11
1-162-974-11
1-126-969-11
1-124-261-00

ELECT
CERAMIC CHIP
CERAMIC CHIP
ELECT
ELECT

22uF
0.022uF
0.01uF
220uF
10uF

20%
20%

50V
50V
50V
50V
50V

C1306
C1307
C1309
C1310
C1311

1-162-974-11
1-107-826-11
1-124-589-11
1-162-927-11
1-126-157-11

CERAMIC CHIP
CERAMIC CHIP
ELECT
CERAMIC CHIP
ELECT

0.01uF
0.1uF
47uF
100PF
10uF

10%
20%
5%
20%

50V
16V
16V
50V
16V

C1312
C1313
C1314
C1315
C1316

1-115-416-11
1-115-416-11
1-115-416-11
1-115-416-11
1-162-927-11

CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP

0.001uF
0.001uF
0.001uF
0.001uF
100PF

5%
5%
5%
5%
5%

25V
25V
25V
25V
50V

C1317
C1318
C1319
C1320
C1321

1-162-927-11
1-162-927-11
1-162-927-11
1-162-927-11
1-162-927-11

CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP

100PF
100PF
100PF
100PF
100PF

5%
5%
5%
5%
5%

50V
50V
50V
50V
50V

C1322
C1323
C1324
C1325
C1326

1-162-927-11
1-162-927-11
1-162-927-11
1-162-927-11
1-162-927-11

CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP

100PF
100PF
100PF
100PF
100PF

5%
5%
5%
5%
5%

50V
50V
50V
50V
50V

C1327
C1328
C1329
C1330
C1331

1-162-927-11
1-162-927-11
1-162-927-11
1-162-927-11
1-162-927-11

CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP

100PF
100PF
100PF
100PF
100PF

5%
5%
5%
5%
5%

50V
50V
50V
50V
50V

C1357

1-107-826-11 CERAMIC CHIP

0.1uF

10%

16V

20%

< CONNECTOR >

CN1402 1-784-747-11 CONNECTOR, FFC 25P
CN1452 1-785-337-11 PIN, CONNECTOR (LIGHT ANGLE) 11P
CN1453 1-818-282-11 PIN, CONNECTOR (FOR PWB) 3P
< DIODE >

< VARIABLE RESISTOR >

RV1400 1-223-983-11 RES, VAR, CARBON 50K (MIC 1 LEVEL)
RV1401 1-223-983-11 RES, VAR, CARBON 50K (MIC 2 LEVEL)
RV1402 1-223-983-11 RES, VAR, CARBON 50K (ECHO LEVEL)
************************************************************

Description
< CAPACITOR >

D1300
D1301
D1302
D1303
D1304

6-501-193-01
6-501-193-01
6-501-193-01
6-501-193-01
6-500-809-01

D1305
D1306
D1313

8-719-059-18 DIODE RD6.2FM-T1

6-501-193-01 DIODE 1SS355WTE-17
6-501-228-01 DIODE SELU5420E-STP15
(SUB WOOFER ON/OFF)
6-501-193-01 DIODE 1SS355WTE-17

D1314

DIODE
DIODE
DIODE
DIODE
DIODE

1SS355WTE-17
1SS355WTE-17
1SS355WTE-17
1SS355WTE-17
SELU5223C-STP15 ( ^/1 )

< FLUORESCENT INDICATOR >

< CONNECTOR >
FL1300 1-519-859-11 VACUUM FLUORESCENT DISPLAYS
CN742 1-784-727-11 CONNECTOR, FFC 5P
************************************************************
A-1167-711-A PANEL BOARD, COMPLETE
**********************

78

< IC >
IC1300

6-709-115-11 IC NJU3427FA2

HCD-GNX660
Ver. 1.1
PANEL
Ref. No.

Part No.

Description

Remarks

< JUMPER RESISTOR >

JR1305 1-216-864-11 SHORT CHIP

Part No.

Description

Remarks

R1355
R1356

1-216-809-11 METAL CHIP

1-216-829-11 METAL CHIP

100
4.7K

5%
5%

1/10W
1/10W

R1357
R1358
R1359
R1360
R1361

1-216-829-11
1-216-829-11
1-216-829-11
1-216-829-11
1-216-829-11

4.7K
4.7K
4.7K
4.7K
4.7K

5%
5%
5%
5%
5%

1/10W
1/10W
1/10W
1/10W
1/10W

< COIL >

L1300

Ref. No.

POWER

1-410-671-31 INDUCTOR

47uH

METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP

< TRANSISTOR >

< SWITCH >
Q1300
Q1303
Q1304
Q1305
Q1306

6-550-065-01
8-729-903-46
8-729-903-46
8-729-027-50
8-729-027-50

TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR

CPH5504-TL-E
2SB1132-P
2SB1132-P
DTC123JKA-T146
DTC123JKA-T146

Q1307
Q1308
Q1309
Q1310
Q1311

8-729-027-50
8-729-027-43
8-729-027-50
8-729-027-43
8-729-027-56

TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR

DTC123JKA-T146
DTC114EKA-T146
DTC123JKA-T146
DTC114EKA-T146
DTC143TKA-T146

Q1312
Q1313
Q1314
Q1315
Q1316

8-729-027-56
8-729-027-56
8-729-027-56
8-729-027-56
8-729-027-56

TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR

DTC143TKA-T146
DTC143TKA-T146
DTC143TKA-T146
DTC143TKA-T146
DTC143TKA-T146

S1300
S1301
S1302
S1307
S1309

1-762-875-21
1-762-875-21
1-762-875-21
1-762-875-21
1-762-875-21

SWITCH, KEYBOARD (DISPLAY)

SWITCH, KEYBOARD ( ^/1 )
SWITCH, KEYBOARD (SUB WOOFER ON/OFF)
SWITCH, KEYBOARD (TV)
SWITCH, KEYBOARD (TAPE A/B)

S1310
S1311
S1312
S1313
S1314

1-762-875-21
1-762-875-21
1-762-875-21
1-762-875-21
1-762-875-21

SWITCH, KEYBOARD ( X )
SWITCH, KEYBOARD ( B )
SWITCH, KEYBOARD (DISC SKIP, EX-CHANGE)
SWITCH, KEYBOARD (DISC 3)
SWITCH, KEYBOARD (DISC 2)

S1315
S1316
S1317
S1320
S1321

1-762-875-21
1-762-875-21
1-762-875-21
1-762-875-21
1-762-875-21

SWITCH, KEYBOARD (DISC 1)

SWITCH, KEYBOARD ( Z OPEN/CLOSE)
SWITCH, KEYBOARD (x)
SWITCH, KEYBOARD (DIRECTION/KARAOKE)
SWITCH, KEYBOARD
(ILLUMINATION/SUB WOOFER LEVEL)
SWITCH, KEYBOARD (TUNER/BAND)
SWITCH, KEYBOARD (CD)
SWITCH, KEYBOARD (CD SYNC)
SWITCH, KEYBOARD (ALBUM- m)
SWITCH, KEYBOARD (ALBUM+ M)

< RESISTOR >

R1300
R1301
R1302
R1303
R1304

1-216-827-11
1-216-837-11
1-216-837-11
1-216-809-11
1-216-809-11

METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP

3.3K
22K
22K
100
100

5%
5%
5%
5%
5%

1/10W
1/10W
1/10W
1/10W
1/10W

S1322
S1323
S1324
S1325
S1326

1-762-875-21
1-762-875-21
1-762-875-21
1-762-875-21
1-762-875-21

R1305
R1307
R1308
R1311
R1313

1-215-871-11
1-216-829-11
1-216-821-11
1-216-825-11
1-216-814-11

METAL OXIDE
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP

2.2K
4.7K
1K
2.2K
270

5%
5%
5%
5%
5%

1W
1/10W
1/10W
1/10W
1/10W

S1327

1-762-875-21 SWITCH, KEYBOARD (REC PAUSE/START)

R1314
R1317
R1318
R1319
R1320

1-216-864-11
1-216-833-11
1-216-829-11
1-216-825-11
1-216-823-11

SHORT CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP

0
10K
4.7K
2.2K
1.5K

5%
5%
5%
5%

1/10W
1/10W
1/10W
1/10W

R1321
R1322
R1323
R1324
R1325

1-216-821-11
1-216-819-11
1-216-817-11
1-216-815-11
1-216-815-11

METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP

1K
680
470
330
330

5%
5%
5%
5%
5%

1/10W
1/10W
1/10W
1/10W
1/10W

R1326
R1327
R1328
R1330
R1331

1-216-817-11
1-216-819-11
1-216-821-11
1-216-815-11
1-216-817-11

METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP

470
680
1K
330
470

5%
5%
5%
5%
5%

1/10W
1/10W
1/10W
1/10W
1/10W

R1332
R1345
R1346
R1347
R1348

1-216-819-11
1-216-809-11
1-216-821-11
1-216-817-11
1-216-821-11

METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP

680
100
1K
470
1K

5%
5%
5%
5%
5%

1/10W
1/10W
1/10W
1/10W
1/10W

R1351
R1352
R1353

1-216-809-11 METAL CHIP

1-216-809-11 METAL CHIP
1-216-809-11 METAL CHIP

100
100
100

5%
5%
5%

1/10W
1/10W
1/10W

< TRANSFORMER >

T1300 1-443-894-11 DC/DC CONVERTER TRANSFORMER
************************************************************
A-1167-598-A POWER BOARD, COMPLETE
**********************
1-533-217-41 FUSE HOLDER
< CAPACITOR >
0 C1101
0 C1107
0 C1109
0 C1110
0 C1112

1-165-529-11
1-165-529-11
1-112-868-11
1-112-868-11
1-144-206-11

MYLAR
MYLAR
CERAMIC
CERAMIC
ELECT (BLOCK)

0 C1113
0 C1115
C1116
0 C1117
0 C1118

1-114-206-11
1-112-867-11
1-117-370-11
1-112-335-91
1-112-841-11

ELECT (BLOCK) 680uF

CERAMIC
220PF
CERAMIC CHIP 10uF
FILM
0.0033uF
CAP, METALIZED PP FILM

5%
820PF

0 C1119
0 C1120
0 C1121
0 C1122
C1123

1-100-566-91
1-162-925-11
1-126-949-11
1-162-967-11
1-136-203-11

CERAMIC CHIP
CERAMIC CHIP
ELECT
CERAMIC CHIP
MYLAR

0.1uF
68PF
220uF
0.0033uF
0.01uF

10%
5%
20%
10%
5%

25V
50V
35V
50V
630V

0.1uF

10%

100V

C1124

1-100-623-91 CERAMIC CHIP

0.22uF
0.22uF
330PF
330PF
680uF

10
10
10%
10%
20%

275V
275V
125V
125V
220V

20%
10%

220V
125V
10V
400V

79

HCD-GNX660
Ver. 1.2
POWER
Ref. No.

Part No.

Description

Remarks

Ref. No.

Part No.

Description

C1125
C1126
C1127
C1129

1-165-761-21
1-165-761-21
1-165-744-11
1-100-566-91

ELECT
ELECT
ELECT
CERAMIC CHIP

1200uF
1200uF
1200uF
0.1uF

20%
20%
20%
10%

63V
63V
35V
25V

D1117
0 D1118
0 D1119
D1120
D1122

8-719-947-79
6-500-593-41
8-719-063-74
8-719-069-54
8-719-071-94

DIODE
DIODE
DIODE
DIODE
DIODE

MTZJ-T-72-22D
10EDB60-TA2B5
D1NL20U-TR2
UDZSTE-175.1B
HRU0103ATRF

Remarks

C1130
C1131
C1134
C1135
C1136

1-162-966-11
1-164-362-11
1-131-976-11
1-128-555-11
1-128-555-11

CERAMIC CHIP
CERAMIC CHIP
ELECT
ELECT
ELECT

0.0022uF
470PF
820uF
470uF
470uF

10%
5%
20%
20%
20%

50V
50V
25V
63V
63V

0 D1200
0 D1202
0 D1203
0 D1204
0 D1205

6-500-849-01
8-719-063-74
8-719-947-79
8-719-063-74
8-719-947-79

DIODE
DIODE
DIODE
DIODE
DIODE

ERA22-08KFLB
D1NL20U-TR2
MTZJ-T-72-22D
D1NL20U-TR2
MTZJ-T-72-22D

C1137
C1138
C1139
C1140
C1147

1-100-623-91
1-126-935-11
1-100-566-91
1-115-339-11
1-128-551-11

CERAMIC CHIP
ELECT
CERAMIC CHIP
CERAMIC CHIP
ELECT

0.1uF
470uF
0.1uF
0.1uF
22uF

10%
20%
10%
10%
20%

100V
16V
25V
50V
63V

0 D1206
0 D1207
0 D1208
0 D1211
D1212

8-719-947-79
8-719-063-74
8-719-083-61
8-719-063-74
6-501-412-01

DIODE
DIODE
DIODE
DIODE
DIODE

MTZJ-T-72-22D
D1NL20U-TR2
UDZSTE-1711B
D1NL20U-TR2
SF5S6

C1148
0 C1149
0 C1149
0 C1150
C1200

1-162-979-11
1-104-663-11
1-126-964-11
1-164-315-11
1-165-136-11

CERAMIC CHIP
ELECT
ELECT
CERAMIC CHIP
CERAMIC

0.0027uF
33uF
10uF
470PF
3300PF

10%
20%
20%
5%
10%

50V
25V (-12)
50V (-13)
50V (-13)
500V

D1213
0 D1214
D1215

8-719-080-53 DIODE RK36LF-B3

8-719-921-40 DIODE MTZJ-4.7C
8-719-947-79 DIODE MTZJ-T-72-22D

0 C1202
0 C1203
0 C1206
0 C1207
0 C1208

1-107-444-11
1-100-566-91
1-162-923-11
1-162-964-11
1-162-969-11

CERAMIC
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP

100PF
0.1uF
47PF
0.001uF
0.0068uF

5%
10%
5%
10%
10%

2KV
25V
50V
50V
25V

0 C1209
0 C1210
0 C1212
C1213
C1214

1-104-665-11
1-126-965-11
1-112-868-11
1-135-372-11
1-100-566-91

ELECT
ELECT
CERAMIC
ELECT
CERAMIC CHIP

100uF
22uF
330PF
470uF
0.1uF

20%
20%
10%
20%
10%

25V
50V
125V
10V
25V

C1216
C1217
C1218
C1219
C1221

1-128-951-21
1-100-566-91
1-100-566-91
1-100-566-91
1-126-935-11

ELECT
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
ELECT

2200uF
0.1uF
0.1uF
0.1uF
470uF

20%
10%
10%
10%
20%

16V
25V
25V
25V
16V

C1222

1-126-964-11 ELECT

10uF

20%

50V

< EARTH TERMINAL >

*
*
*
*
*

EP1100
EP1101
EP1102
EP1103
EP1104

1-537-738-21
1-537-738-21
1-537-738-21
1-537-738-21
1-537-738-21

TERMINAL, EARTH
TERMINAL, EARTH
TERMINAL, EARTH
TERMINAL, EARTH
TERMINAL, EARTH

* EP1105 1-537-738-21 TERMINAL, EARTH

* EP1106 1-537-738-21 TERMINAL, EARTH
* EP1200 1-537-738-21 TERMINAL, EARTH
< IC >
0 IC1100
IC1101
IC1102
0 IC1200
IC1201

6-709-168-01
6-707-743-01
6-701-021-01
6-707-962-01
6-707-743-01

IC
IC
IC
IC
IC

MR5060
TA76L431S (TPE6, Q)
SI-8120JF
MR1722
TA76L431S (TPE6, Q)

< JUMPER RESISTOR >

< CONNECTOR >
* CN1101 1-564-243-11 PIN, CONNECTOR (3.96mm PITCH) 6P
* CN1200 1-564-510-11 PLUG, CONNECTOR 7P
CNP1100 1-564-321-00 PIN, CONNECTOR (3.96mm PITCH) 2P

JR1101
JR1103
JR1105
JR1106
JR1107

1-216-864-11
1-216-864-11
1-216-864-11
1-216-296-11
1-216-296-11

SHORT CHIP
SHORT CHIP
SHORT CHIP
SHORT CHIP
SHORT CHIP

0
0
0
0
0

< DIODE >

0 D1100
0 D1101
0 D1102
0 D1103
0 D1106

8-719-082-57
8-719-068-00
8-719-068-00
6-500-241-01
8-719-030-33

DIODE
DIODE
DIODE
DIODE
DIODE

D5SBA60F01
ERC04-06SE
ERC04-06SE
SARS03
EG01CV1

0 D1107
0 D1108
0 D1109
0 D1110
0 D1111

8-719-947-79
8-719-947-79
8-719-947-79
8-719-063-74
8-719-083-52

DIODE
DIODE
DIODE
DIODE
DIODE

MTZJ-T-72-22D
MTZJ-T-72-22D
MTZJ-T-72-22D
D1NL20U-TR2
UDZSTE-1716B

0 D1112
D1113
D1114
D1115
D1116

8-719-063-74
6-501-398-01
6-501-411-01
8-719-069-54
8-719-080-53

DIODE
DIODE
DIODE
DIODE
DIODE

D1NL20U-TR2
FCH20A20
SF20NC15M
UDZSTE-175.1B
RK36LF-B3

80

0 JR1108 1-216-296-11 SHORT CHIP

0 JR1150 1-216-864-11 SHORT CHIP

0
0 (-13)

< COIL >

L1100
L1102
L1200
L1201

1-457-058-21
1-456-545-11
1-410-470-11
1-456-545-11

COIL, CHOKE
INDUCTOR
INDUCTOR
INDUCTOR

10uH
100uH
10uH
100uH

< LINE FILTER >

0 LF1101 1-457-268-11 LINE FILTER COIL
< PHOTO COUPLER >
0 PC1100 6-600-438-01 IC TLP421F (D4-GR)
0 PC1101 6-600-438-01 IC TLP421F (D4-GR)

HCD-GNX660
Ver. 1.2
SENSOR

POWER
Ref. No.

Part No.

Description

Remarks

0 PC1102 6-600-438-01 IC TLP421F (D4-GR)

0 PC1200 6-600-438-01 IC TLP421F (D4-GR)
< TRANSISTOR >
Q1100
Q1101
0 Q1102
0 Q1200
Q1203
Q1204
Q1205
Q1206

8-729-271-31
8-729-271-31
8-729-271-31
8-729-271-31
6-551-460-01

TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR

2SC2713-G
2SC2713-G
2SC2713-G
2SC2713-G
RSR25P03TL

8-729-271-31 TRANSISTOR 2SC2713-G

8-729-271-31 TRANSISTOR 2SC2713-G
6-551-460-01 TRANSISTOR RSR25P03TL
< RESISTOR >

0 R1103
0 R1105
0 R1106
0 R1108
0 R1109

1-242-949-11
1-215-929-11
1-215-929-11
1-216-343-00
1-243-669-11

0 R1110

FUSIBLE
METAL OXIDE
METAL OXIDE
METAL OXIDE
METAL

0.1
100K
100K
0.33
0.05

10%
5%
5%
5%
5%

1W
3W
3W
1W
5W

1-216-833-11 METAL CHIP

10K

5%

0 R1110

1-216-835-11 METAL CHIP

15K

5%

0 R1111
0 R1112
0 R1113

1-216-838-11 METAL CHIP

1-216-841-11 METAL CHIP
1-249-389-11 CARBON

27K
47K
4.7

5%
5%
5%

1/10W
(-13)
1/10W
(-12)
1/10W
1/10W
1/4W

0 R1114
0 R1115
0 R1116
R1117
0 R1118

1-216-837-11
1-216-829-11
1-216-864-11
1-218-859-11
1-246-097-31

METAL CHIP
METAL CHIP
SHORT CHIP
METAL CHIP
METAL OXIDE

22K
4.7K
0
3.3K
1

5%
5%

1/10W
1/10W

0.5%
5%

1/10W
2W

0 R1120
R1121
R1122
R1123
R1124

1-219-769-11
1-218-867-11
1-218-855-11
1-218-861-11
1-218-889-11

METAL
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP

3.3M
6.8K
2.2K
3.9K
56K

5%
0.5%
0.5%
0.5%
0.5%

1/2W
1/10W
1/10W
1/10W
1/10W

R1126
R1127
R1128
R1129
R1130

1-216-864-11
1-216-841-11
1-218-853-11
1-218-867-11
1-218-867-11

SHORT CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP

0
47K
1.8K
6.8K
6.8K

5%
0.5%
0.5%
0.5%

1/10W
1/10W
1/10W
1/10W

R1131
R1132
R1133
R1135
R1136

1-216-833-11
1-216-833-11
1-216-833-11
1-216-864-11
1-216-864-11

METAL CHIP
METAL CHIP
METAL CHIP
SHORT CHIP
SHORT CHIP

10K
10K
10K
0
0

5%
5%
5%

1/10W
1/10W
1/10W

0 R1137
0 R1138
R1139
R1140
0 R1141

1-247-895-00
1-247-895-00
1-216-833-11
1-216-821-11
1-218-867-11

CARBON
CARBON
METAL CHIP
METAL CHIP
METAL CHIP

470K
470K
10K
1K
6.8K

5%
5%
5%
5%
0.5%

1/4W
1/4W
1/10W
1/10W
1/10W
(-12)

0 R1141

1-216-833-11 METAL CHIP

10K

5%

0 R1142

1-216-841-11 METAL CHIP

47K

5%

0 R1142

1-216-853-11 METAL CHIP

470K

5%

1/10W
(-13)
1/10W
(-12)
1/10W
(-13)

Ref. No.

Part No.

0 R1143
R1144

1-216-827-11 METAL CHIP

1-216-833-11 METAL CHIP

Description
3.3K
10K

5%
5%

Remarks
1/10W (-13)
1/10W

R1145
R1146
0 R1147
0 R1152
0 R1200

1-216-809-11
1-218-867-11
1-216-830-11
1-216-841-11
1-215-904-61

METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL OXIDE

100
6.8K
5.6K
47K
100K

5%
0.5%
5%
5%
5%

1/10W
1/10W
1/10W (-13)
1/10W (-13)
2W

0 R1201
0 R1202
0 R1203
0 R1207
0 R1208

1-249-478-11
1-216-839-11
1-249-393-11
1-216-829-11
1-216-834-11

CARBON
METAL CHIP
CARBON
METAL CHIP
METAL CHIP

2.2
33K
10
4.7K
12K

5%
5%
5%
5%
5%

1/2W
1/10W
1/4W
1/10W
1/10W

0 R1209
0 R1210
0 R1211
R1212
0 R1214

1-216-825-11
1-216-835-11
1-216-821-11
1-216-833-11
1-249-381-11

METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
CARBON

2.2K
15K
1K
10K
1

5%
5%
5%
5%
5%

1/10W
1/10W
1/10W
1/10W
1/4W

R1215
R1216
R1217
R1218
R1219

1-216-821-11
1-216-813-11
1-216-841-11
1-218-867-11
1-218-855-11

METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP

1K
220
47K
6.8K
2.2K

5%
5%
5%
0.5%
0.5%

1/10W1/10W
1/10W
1/10W
1/10W

R1220
R1221
0 R1223
0 R1224
R1225

1-218-831-11
1-218-861-11
1-216-833-11
1-216-843-11
1-216-809-11

METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP

220
3.9K
10K
68K
100

0.5%
0.5%
5%
5%
5%

1/10W
1/10W
1/10W
1/10W
1/10W

R1226
R1227
R1228
R1229
R1230

1-216-857-11
1-216-845-11
1-216-815-11
1-216-833-11
1-216-821-11

METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP

1M
100K
330
10K
1K

5%
5%
5%
5%
5%

1/10W
1/10W
1/10W
1/10W
1/10W

R1231
R1232
R1233
R1234

1-215-866-11
1-216-833-11
1-216-833-11
1-216-841-11

METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP

330
10K
10K
47K

5%
5%
5%
5%

1W
1/10W
1/10W
1/10W

< TRANSFORMER >

0 T1100
0 T1200

1-443-893-11 POWER TRANSFORMER

1-443-895-11 POWER TRANSFORMER
< THERMISTOR >

0 TH1100 1-805-841-21 THERMISTOR, NTC 3.0

< VARISTOR >
0 VD1100 1-805-482-11 VARISTOR
************************************************************
1-687-132-12 SENSOR BOARD
*************
< CONNECTOR >
CN731

1-785-329-21 PIN, CONNECTOR (LIGHT ANGLE) 3P

< IC >

IC731
6-600-022-01 IC RPI-576
************************************************************

81

HCD-GNX660
SMASTER
Ref. No.

Part No.

Description

Remarks

A-1164-113-A SMASTER BOARD, COMPLETE

*************************
< CAPACITOR >
C504
C505
C506
C507
C508

1-107-826-11
1-107-826-11
1-107-826-11
1-107-826-11
1-107-826-11

CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP

0.1uF
0.1uF
0.1uF
0.1uF
0.1uF

10%
10%
10%
10%
10%

16V
16V
16V
16V
16V

C509
C510
C511
C512
C513

1-104-658-91
1-107-826-11
1-107-826-11
1-107-826-11
1-107-826-11

ELECT
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP

100uF
0.1uF
0.1uF
0.1uF
0.1uF

20%
10%
10%
10%
10%

10V
16V
16V
16V
16V

C520
C521
C522
C523
C524

1-162-964-11
1-162-964-11
1-162-964-11
1-162-964-11
1-162-964-11

CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP

0.001uF
0.001uF
0.001uF
0.001uF
0.001uF

10%
10%
10%
10%
10%

50V
50V
50V
50V
50V

C525
C526
C527
C528
C529

1-162-964-11
1-162-962-11
1-162-962-11
1-162-970-11
1-162-970-11

CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP

0.001uF
470PF
470PF
0.01uF
0.01uF

10%
10%
10%
10%
10%

50V
50V
50V
50V
50V

C531
C532
C533
C534
C535

1-107-826-11
1-107-826-11
1-104-662-91
1-107-826-11
1-107-826-11

CERAMIC CHIP
CERAMIC CHIP
ELECT
CERAMIC CHIP
CERAMIC CHIP

0.1uF
0.1uF
22uF
0.1uF
0.1uF

10%
10%
20%
10%
10%

16V
16V
25V
16V
16V

C536
C537
C538
C544
C545

1-100-436-91
1-100-623-91
1-114-119-31
1-100-623-91
1-114-119-31

CERAMIC CHIP
CERAMIC CHIP
ELECT
CERAMIC CHIP
ELECT

0.033uF
0.1uF
120uF
0.1uF
120uF

10%
10%
20%
10%
20%

25V
100V
63V
100V
63V

C547
C548
C549
C551
C552

1-100-436-91
1-100-623-91
1-135-632-51
1-107-826-11
1-107-826-11

CERAMIC CHIP
CERAMIC CHIP
ELECT
CERAMIC CHIP
CERAMIC CHIP

0.033uF
0.1uF
2200uF
0.1uF
0.1uF

10%
10%
20%
10%
10%

25V
100V
63V
16V
16V

C553
C554
C555
C556
C557

1-124-248-00
1-107-826-11
1-107-826-11
1-100-436-91
1-100-623-91

ELECT
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP

22uF
0.1uF
0.1uF
0.033uF
0.1uF

20%
10%
10%
10%
10%

25V
16V
16V
25V
100V

C558
C564
C565
C567
C568

1-114-119-31
1-100-623-91
1-114-119-31
1-100-436-91
1-100-623-91

ELECT
CERAMIC CHIP
ELECT
CERAMIC CHIP
CERAMIC CHIP

120uF
0.1uF
120uF
0.033uF
0.1uF

20%
10%
20%
10%
10%

63V
100V
63V
25V
100V

C569
C574
C575
C576
C577

1-135-632-51
1-114-160-91
1-114-160-91
1-114-160-91
1-114-160-91

ELECT
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP

2200uF
1uF
1uF
1uF
1uF

20%
10%
10%
10%
10%

63V
100V
100V
100V
100V

C578
C579
C580
C581

1-162-964-11
1-162-964-11
1-135-618-11
1-125-898-91

CERAMIC CHIP
CERAMIC CHIP
MYLAR
CERAMIC CHIP

0.001uF
0.001uF
1uF
0.22uF

10%
10%
5%
10%

50V
50V
63V
50V

82

Ref. No.

Part No.

Description

Remarks

C582

1-162-966-11 CERAMIC CHIP

0.0022uF 10%

50V

C583
C584
C585
C586
C587

1-162-966-11
1-135-618-11
1-125-898-91
1-162-966-11
1-162-966-11

CERAMIC CHIP
MYLAR
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP

0.0022uF
1uF
0.22uF
0.0022uF
0.0022uF

10%
5%
10%
10%
10%

50V
63V
50V
50V
50V

C590
C591
C592
C593
C594

1-135-618-11
1-125-898-91
1-162-966-11
1-162-966-11
1-135-618-11

MYLAR
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
MYLAR

1uF
0.22uF
0.0022uF
0.0022uF
1uF

5%
10%
10%
10%
5%

63V
50V
50V
50V
63V

C595
C596
C597
C604
C605

1-125-898-91
1-162-966-11
1-162-966-11
1-107-826-11
1-107-826-11

CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP

0.22uF
0.0022uF
0.0022uF
0.1uF
0.1uF

10%
10%
10%
10%
10%

50V
50V
50V
16V
16V

C606
C607
C608
C609
C610

1-107-826-11
1-107-826-11
1-107-826-11
1-104-658-91
1-107-826-11

CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
ELECT
CERAMIC CHIP

0.1uF
0.1uF
0.1uF
100uF
0.1uF

10%
10%
10%
20%
10%

16V
16V
16V
10V
16V

C611
C612
C613
C620
C621

1-107-826-11
1-107-826-11
1-107-826-11
1-162-964-11
1-162-964-11

CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP

0.1uF
0.1uF
0.1uF
0.001uF
0.001uF

10%
10%
10%
10%
10%

16V
16V
16V
50V
50V

C622
C623
C626
C629
C651

1-162-964-11
1-162-964-11
1-162-962-11
1-162-970-11
1-107-826-11

CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP

0.001uF
0.001uF
470PF
0.01uF
0.1uF

10%
10%
10%
10%
10%

50V
50V
50V
50V
16V

C652
C653
C654
C655
C656

1-107-826-11
1-104-662-91
1-107-826-11
1-107-826-11
1-100-436-91

CERAMIC CHIP
ELECT
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP

0.1uF
22uF
0.1uF
0.1uF
0.033uF

10%
20%
10%
10%
10%

16V
25V
16V
16V
25V

C657
C658
C664
C665
C667

1-100-623-91
1-114-119-31
1-100-623-91
1-114-119-31
1-100-436-91

CERAMIC CHIP
ELECT
CERAMIC CHIP
ELECT
CERAMIC CHIP

0.1uF
120uF
0.1uF
120uF
0.033uF

10%
20%
10%
20%
10%

100V
63V
100V
63V
25V

C668
C669
C676
C677
C690

1-100-623-91
1-135-632-51
1-114-160-91
1-114-160-91
1-135-618-11

CERAMIC CHIP
ELECT
CERAMIC CHIP
CERAMIC CHIP
MYLAR

0.1uF
2200uF
1uF
1uF
1uF

10%
20%
10%
10%
5%

100V
63V
100V
100V
63V

C691
C692
C693
C694
C695

1-125-898-91
1-162-966-11
1-162-966-11
1-135-618-11
1-125-898-91

CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
MYLAR
CERAMIC CHIP

0.22uF
0.0022uF
0.0022uF
1uF
0.22uF

10%
10%
10%
5%
10%

50V
50V
50V
63V
50V

C696
C697
C800
C801
C802

1-162-966-11
1-162-966-11
1-104-662-91
1-162-970-11
1-162-910-11

CERAMIC CHIP
CERAMIC CHIP
ELECT
CERAMIC CHIP
CERAMIC CHIP

0.0022uF
0.0022uF
22uF
0.01uF
5PF

10%
10%
20%
10%
0.25PF

50V
50V
25V
25V
50V

C803

1-162-964-11 CERAMIC CHIP

0.001uF

10%

50V

HCD-GNX660
Ver. 1.2
SMASTER
Ref. No.

Part No.

Description

Part No.

Description

C804
C805
C806
C809

1-162-915-11
1-104-658-91
1-162-970-11
1-107-826-11

CERAMIC CHIP
ELECT
CERAMIC CHIP
CERAMIC CHIP

10PF
100uF
0.01uF
0.1uF

0.5PF
20%
10%
10%

Remarks
50V
10V
25V
16V

D883
D884
D885
D888

1-216-295-91
1-216-295-91
1-216-295-91
1-216-295-91

SHORT CHIP
SHORT CHIP
SHORT CHIP
SHORT CHIP

C810
C811
C830
C840

1-104-658-91
1-162-970-11
1-126-964-11
1-126-934-11

ELECT
CERAMIC CHIP
ELECT
ELECT

100uF
0.01uF
10uF
220uF

20%
10%
20%
20%

D889
D890
D891
D892
D893

1-216-295-91
1-216-295-91
1-216-295-91
8-719-988-61
8-719-988-61

SHORT CHIP
0 (-12)
SHORT CHIP
0 (-12)
SHORT CHIP
0 (-12)
DIODE 1SS355TE-17
DIODE 1SS355TE-17

C840

1-164-337-11 CERAMIC CHIP

10V
25V
50V
16V
(-13, -21)
16V
(-12)

D895
D896

1-216-295-91 SHORT CHIP

1-216-295-91 SHORT CHIP

2.2uF

C850
C855
C865
C871
C872

1-117-370-11
1-117-370-11
1-117-370-11
1-216-864-11
1-216-864-11

CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
SHORT CHIP
SHORT CHIP

10uF
10uF
10uF
0 (-12)
0 (-12)

C873
C876
C877
C878
C879

1-216-864-11
1-216-864-11
1-216-864-11
1-107-826-11
1-216-864-11

SHORT CHIP
SHORT CHIP
SHORT CHIP
CERAMIC CHIP
SHORT CHIP

0 (-12)
0 (-12)
0 (-12)
0.1uF
0 (-12)

C880
C881
C882
C883
C884

1-162-927-11
1-162-927-11
1-162-927-11
1-126-925-91
1-162-927-11

CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
ELECT
CERAMIC CHIP

C885
C886
C887
C888
C889

1-162-927-11
1-126-935-11
1-126-925-91
1-119-774-11
1-107-826-11

C890
C891
C892

Ref. No.

10V
10V
10V

10%

16V

100PF
100PF
100PF
470uF
100PF

5%
5%
5%
20%
5%

50V
50V
50V
10V
50V

CERAMIC CHIP
ELECT
ELECT
ELECT
CERAMIC CHIP

100PF
470uF
470uF
100uF
0.1uF

5%
20%
20%
20%
10%

50V
16V
10V
16V
16V

1-119-774-11 ELECT
1-107-826-11 CERAMIC CHIP
1-162-927-11 CERAMIC CHIP

100uF
0.1uF
100PF

20%
10%
5%

16V
16V
50V

Remarks
0 (-12)
0 (-12)
0 (-12)
0 (-12)

0 (-12)
0 (-12)

< EARTH TERMINAL >

EP880
EP881
EP882
EP884
EP885

1-537-738-21
1-537-738-21
1-537-738-21
1-537-738-21
1-537-738-21

TERMINAL, GROUND
TERMINAL, GROUND
TERMINAL, GROUND
TERMINAL, GROUND
TERMINAL, GROUND

EP886

1-537-738-21 TERMINAL, GROUND

< FERRITE BEAD >

FB800
FB801
FB881

1-216-864-11 SHORT CHIP

1-216-864-11 SHORT CHIP
1-216-295-91 SHORT CHIP

0
0
0

< FILTER >

FL800
FL801
FL810

1-234-177-21 FILTER, CHIP EMI

1-234-177-21 FILTER, CHIP EMI
1-234-177-21 FILTER, CHIP EMI
< IC >

< CONNECTOR >

CN500
* CN501
* CN502
CN503

1-784-780-11
1-564-712-11
1-564-243-11
1-564-705-11

CONNECTOR, FFC 19P

PIN, CONNECTOR (SMALL TYPE) 10P
PIN, CONNECTOR (3.96mm PITCH) 6P (-12)
PIN, CONNECTOR (SMALL TYPE) 3P

IC500
IC530
IC550
IC600
IC650

6-707-939-01
6-709-087-01
6-709-087-01
6-707-939-01
6-709-087-01

IC
IC
IC
IC
IC

CXD9843AR
CXD9879M
CXD9879M
CXD9843AR
CXD9879M

IC800
IC802
IC810
IC880

6-701-189-01
6-701-189-01
6-700-263-01
8-759-422-21

IC
IC
IC
IC

MC74VHC1GU04DFT1
MC74VHC1GU04DFT1
NJM2870F18 (TE2)
NJM4580V (TE2)

< DIODE >

< COIL >
D533
D534
D535
D536
D553

6-501-484-01
6-501-484-01
6-501-485-01
6-501-485-01
6-501-484-01

DIODE
DIODE
DIODE
DIODE
DIODE

P6SMB62AT3
P6SMB62AT3
EC10UA20
EC10UA20
P6SMB62AT3

D554
D555
D556
D653
D654

6-501-484-01
6-501-485-01
6-501-485-01
6-501-484-01
6-501-484-01

DIODE
DIODE
DIODE
DIODE
DIODE

P6SMB62AT3
EC10UA20
EC10UA20
P6SMB62AT3
P6SMB62AT3

D655
D656
D820
D880
D881

6-501-485-01
6-501-485-01
8-719-988-61
1-216-295-91
1-216-295-91

DIODE EC10UA20
DIODE EC10UA20
DIODE 1SS355TE-17
SHORT CHIP
0 (-12)
SHORT CHIP
0 (-12)

D882

1-216-295-91 SHORT CHIP

0 (-12)

L580
L581
L590
L591
L690

1-457-237-11
1-457-237-11
1-457-237-11
1-457-237-11
1-457-237-11

CHOKE COIL
CHOKE COIL
CHOKE COIL
CHOKE COIL
CHOKE COIL

10uH
10uH
10uH
10uH
10uH

L691
L800
L801
L802

1-457-237-11
1-216-295-91
1-412-939-11
1-216-295-91

CHOKE COIL
SHORT CHIP
INDUCTOR
SHORT CHIP

10uH
0
1uH
0

< TRANSISTOR >

Q840
Q850
Q851
Q855
Q856

8-729-120-28
8-729-602-36
8-729-602-36
8-729-602-36
8-729-602-36

TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR

2SC1623-L5L6
2SA1602-F
2SA1602-F
2SA1602-F
2SA1602-F

83

HCD-GNX660
Ver. 1.2
SMASTER
Ref. No.
Q865
Q866

Part No.

Description

Remarks

Part No.

Description

R583
R591
R593
R600
R601

1-216-790-11
1-216-790-11
1-216-790-11
1-216-864-11
1-216-864-11

METAL CHIP
METAL CHIP
METAL CHIP
SHORT CHIP
SHORT CHIP

2.7
2.7
2.7
0
0

5%
5%
5%

1/10W
1/10W
1/10W

R602
R603
R605
R606
R607

1-216-833-11
1-216-809-11
1-216-817-11
1-216-817-11
1-216-817-11

METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP

10K
100
470
470
470

5%
5%
5%
5%
5%

1/10W
1/10W
1/10W
1/10W
1/10W

R609
R610
R612
R615
R616

1-216-864-11
1-216-864-11
1-216-833-11
1-216-806-11
1-216-809-11

SHORT CHIP
SHORT CHIP
METAL CHIP
METAL CHIP
METAL CHIP

0
0
10K
56
100

5%
5%
5%

1/10W
1/10W
1/10W

R617
R619
R620
R621
R623

1-216-809-11
1-216-821-11
1-216-821-11
1-216-821-11
1-216-864-11

METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
SHORT CHIP

100
1K
1K
1K
0

5%
5%
5%
5%

1/10W
1/10W
1/10W
1/10W

R624
R650
R650
R651
R652

1-216-864-11
1-216-797-11
1-216-864-11
1-216-809-11
1-216-809-11

SHORT CHIP
METAL CHIP
SHORT CHIP
METAL CHIP
METAL CHIP

0
10
5%
0 (-13, -21)
100
5%
100
5%

1/10W
1/10W

R653
R655
R657
R658
R661

1-216-809-11
1-216-839-11
1-216-142-00
1-216-142-00
1-216-797-11

METAL CHIP
METAL CHIP
RES-CHIP
RES-CHIP
METAL CHIP

100
33K
4.7
4.7
10

5%
5%
5%
5%

1/10W
1/10W
1/10W
1/10W
(-12)

R662
R662
R667
R668
R669

1-216-797-11
1-216-864-11
1-219-107-91
1-219-107-91
1-216-791-11

METAL CHIP
SHORT CHIP
RES-CHIP
RES-CHIP
METAL CHIP

10
5%
0 (-13, -21)
1.5
5%
1.5
5%
3.3
5%

1/10W (-12)

5%
5%
5%
5%

1/8W
1/8W
1/10W
1/10W
(-12)

R691
R693
R800
R801
R802

1-216-790-11
1-216-790-11
1-216-857-11
1-216-809-11
1-216-806-11

METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP

2.7
2.7
1M
100
56

5%
5%
5%
5%
5%

1/10W
1/10W
1/10W
1/10W
1/10W

R804
R805
R806
R807
R809

1-216-864-11
1-216-864-11
1-216-864-11
1-216-864-11
1-216-806-11

SHORT CHIP
SHORT CHIP
SHORT CHIP
SHORT CHIP
METAL CHIP

0
0
0
0
56

5%

1/10W

R811
R820
R821
R822
R823

1-216-845-11
1-216-837-11
1-216-823-11
1-216-837-11
1-216-837-11

METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP

100K
22K
1.5K
22K
22K

5%
5%
5%
5%
5%

1/10W
1/10W
1/10W
1/10W
1/10W

R840
R841
R850
R851
R852

1-216-845-11
1-216-864-11
1-216-845-11
1-216-845-11
1-216-845-11

METAL CHIP
SHORT CHIP
METAL CHIP
METAL CHIP
METAL CHIP

100K
0
100K
100K
100K

5%

1/10W

5%
5%
5%

1/10W
1/10W
1/10W

R855
R856
R857

1-216-845-11 METAL CHIP

1-216-845-11 METAL CHIP
1-216-845-11 METAL CHIP

100K
100K
100K

5%
5%
5%

1/10W
1/10W
1/10W

8-729-602-36 TRANSISTOR 2SA1602-F

8-729-602-36 TRANSISTOR 2SA1602-F
< RESISTOR >

R500
R501
R502
R503
R505

1-216-864-11
1-216-864-11
1-216-833-11
1-216-809-11
1-216-817-11

SHORT CHIP
SHORT CHIP
METAL CHIP
METAL CHIP
METAL CHIP

0
0
10K
100
470

R506
R507
R509
R510
R511

1-216-817-11
1-216-817-11
1-216-864-11
1-216-864-11
1-216-864-11

METAL CHIP
METAL CHIP
SHORT CHIP
SHORT CHIP
SHORT CHIP

R512
R515
R516
R517
R519

1-216-833-11
1-216-806-11
1-216-809-11
1-216-809-11
1-216-821-11

R520
R521
R523
R524
R526

1-216-821-11
1-216-821-11
1-216-864-11
1-216-864-11
1-216-864-11

5%
5%
5%

1/10W
1/10W
1/10W

470
470
0
0
0

5%
5%

1/10W
1/10W

METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP

10K
56
100
100
1K

5%
5%
5%
5%
5%

1/10W
1/10W
1/10W
1/10W
1/10W

METAL CHIP
METAL CHIP
SHORT CHIP
SHORT CHIP
SHORT CHIP

1K
1K
0
0
0

5%
5%

1/10W
1/10W

R529
R530

1-216-864-11 SHORT CHIP

1-216-797-11 METAL CHIP

0
10

R530
R531
R532

1-216-864-11 SHORT CHIP

1-216-809-11 METAL CHIP
1-216-809-11 METAL CHIP

0 (-13, -21)
100
5%
100
5%

R533
R535
R541
R542

1-216-809-11
1-216-839-11
1-216-797-11
1-216-797-11

100
33K
10
10

R542

1-216-864-11 SHORT CHIP

0 (-13, -21)

R547
R548
R549
R550

1-219-107-91
1-219-107-91
1-216-791-11
1-216-797-11

1.5
1.5
3.3
10

R550

1-216-864-11 SHORT CHIP

0 (-13, -21)

R551
R552
R553
R555
R557

1-216-809-11
1-216-809-11
1-216-809-11
1-216-839-11
1-216-142-00

METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
RES-CHIP

100
100
100
33K
4.7

5%
5%
5%
5%
5%

1/10W
1/10W
1/10W
1/10W
1/8W

R558
R559
R560
R561
R562

1-216-142-00
1-216-142-00
1-216-142-00
1-216-797-11
1-216-797-11

RES-CHIP
RES-CHIP
RES-CHIP
METAL CHIP
METAL CHIP

4.7
4.7
4.7
10
10

5%
5%
5%
5%
5%

1/8W
1/8W
1/8W
1/10W
1/10W
(-12)

R562
R567
R568
R569
R581

1-216-864-11
1-219-107-91
1-219-107-91
1-216-791-11
1-216-790-11

SHORT CHIP
RES-CHIP
RES-CHIP
METAL CHIP
METAL CHIP

0 (-13, -21)
1.5
5%
1.5
5%
3.3
5%
2.7
5%

84

METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP

RES-CHIP
RES-CHIP
METAL CHIP
METAL CHIP

5%

1/10W
(-12)

1/8W
1/8W
1/10W
1/10W

Ref. No.

Remarks

5%
5%
5%
5%
5%

1/10W (-12)
1/10W
1/10W
1/10W
1/10W
1/8W
1/8W
1/10W

1/8W
1/8W
1/10W

HCD-GNX660
Ver. 1.1
SMASTER
Ref. No.

Part No.

Description

Remarks

Ref. No.

Part No.

SPEAKER

SW

Description

Remarks

R858
R859

1-216-841-11 METAL CHIP

1-216-841-11 METAL CHIP

47K
47K

5%
5%

1/10W
1/10W

VOL BOARD
**********

R865
R866
R867
R868
R880

1-216-845-11
1-216-845-11
1-216-845-11
1-216-841-11
1-216-837-11

METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP

100K
100K
100K
47K
22K

5%
5%
5%
5%
5%

1/10W
1/10W
1/10W
1/10W
1/10W

< CAPACITOR >

C1334

R881
R882
R883
R884
R885

1-216-837-11
1-216-837-11
1-216-837-11
1-216-837-11
1-216-839-11

METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP

22K
22K
22K
22K
33K

5%
5%
5%
5%
5%

1/10W
1/10W
1/10W
1/10W
1/10W

D1307
D1308
D1309
D1310
D1311

6-500-809-01
6-500-809-01
6-500-809-01
6-500-809-01
6-500-809-01

R886
R887
R888
R889
R890

1-216-864-11
1-216-837-11
1-216-837-11
1-216-837-11
1-216-837-11

SHORT CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP

0
22K
22K
22K
22K

D1312

6-500-809-01 DIODE SELU5223C-STP15 (LED 4)

5%
5%
5%
5%

1/10W
1/10W
1/10W
1/10W

R891
R892
R893
R894
R895

1-216-839-11
1-216-864-11
1-216-826-11
1-216-825-11
1-216-837-11

METAL CHIP
SHORT CHIP
METAL CHIP
METAL CHIP
METAL CHIP

33K
0
2.7K
2.2K
22K

5%

1/10W

5%
5%
5%

1/10W
1/10W
1/10W

< VIBRATOR >

X800
1-795-660-21 QUARTZ CRYSTAL UNIT (49.152MHz)
************************************************************
SPEAKER BOARD
**************
< CAPACITOR >

1-164-360-11 CERAMIC CHIP

VOL

0.1uF

16V

< DIODE >

DIODE
DIODE
DIODE
DIODE
DIODE

SELU5223C-STP15 (LED 1)
SELU5223C-STP15 (LED 2)
SELU5223C-STP15 (LED 3)
SELU5223C-STP15 (LED 6)
SELU5223C-STP15 (LED 5)

< JUMPER RESISTOR >

JR1300 1-216-864-11 SHORT CHIP
JR1301 1-216-864-11 SHORT CHIP
JR1302 1-216-864-11 SHORT CHIP

0
0
0

< RESISTOR >

R1329
R1333
R1334
R1335
R1336

1-216-823-11
1-216-821-11
1-216-823-11
1-216-825-11
1-216-829-11

METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP

1.5K
1K
1.5K
2.2K
4.7K

5%
5%
5%
5%
5%

1/10W
1/10W
1/10W
1/10W
1/10W

R1337
R1362
R1363
R1364
R1365

1-216-833-11
1-216-821-11
1-216-821-11
1-216-821-11
1-216-821-11

METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP

10K
1K
1K
1K
1K

5%
5%
5%
5%
5%

1/10W
1/10W
1/10W
1/10W
1/10W

C1502
C1512
C1522
C1532
C1602

1-162-964-11
1-162-964-11
1-162-964-11
1-162-964-11
1-162-964-11

CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP

0.001uF
0.001uF
0.001uF
0.001uF
0.001uF

10%
10%
10%
10%
10%

50V
50V
50V
50V
50V

R1366
R1367
R1368
R1369
R1370

1-216-821-11
1-216-821-11
1-216-821-11
1-216-821-11
1-216-821-11

METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP

1K
1K
1K
1K
1K

5%
5%
5%
5%
5%

1/10W
1/10W
1/10W
1/10W
1/10W

C1612

1-162-964-11 CERAMIC CHIP

0.001uF

10%

50V

R1371
R1372
R1373
R1374
R1375

1-216-821-11
1-216-821-11
1-216-821-11
1-216-821-11
1-216-821-11

METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP

1K
1K
1K
1K
1K

5%
5%
5%
5%
5%

1/10W
1/10W
1/10W
1/10W
1/10W

R1376
R1377
R1378
R1379

1-216-821-11
1-216-821-11
1-216-821-11
1-216-821-11

METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP

1K
1K
1K
1K

5%
5%
5%
5%

1/10W
1/10W
1/10W
1/10W

< CONNECTOR >

* CN1500 1-564-241-11 PIN, CONNECTOR (3.96mm PITCH) 4P
CN1600 1-564-320-00 PIN, CONNECTOR (3.96mm PITCH) 2P
< EARTH TERMINAL >
* EP1500 1-537-738-21 TERMINAL, EARTH
* EP1501 1-537-738-21 TERMINAL, EARTH

< SWITCH >

< TERMINAL >
S1305
TM1500 1-820-057-11 CONNECTOR (SPEAKER) 3P
(SUB WOOFER, FRONT SPEAKER)
************************************************************
1-687-669-12 SW BOARD
********
< SWITCH >

S1306
S1318
S1319
S1328

1-418-725-41 ENCODER, ROTARY (12 TYPE)

(MASTER VOLUME)
1-786-289-31 SWITCH, DETECTION (OPERATION DIAL)
1-762-875-21 SWITCH, KEYBOARD (EQ BAND/MEMORY)
1-762-875-21 SWITCH, KEYBOARD (MP3 BOOSTER)
1-762-875-21 SWITCH, KEYBOARD (PRESET EQ)

S1331 1-762-875-21 SWITCH, KEYBOARD (GROOVE)

************************************************************

S751
1-786-514-11 SWITCH, LEVER (SLIDE) (OPEN)
************************************************************

85

HCD-GNX660

Ref. No.

Part No.

Description
MISCELLANEOUS
**************

7
10
11
12
14

1-693-702-11
1-775-284-11
1-829-030-11
1-827-720-11
1-828-973-11

TUNER (FM/AM) (TM10SE)

WIRE (FLAT TYPE) (31 CORE)
WIRE (FLAT TYPE) (25 CORE)
WIRE (FLAT TYPE) (11 CORE)
WIRE (FLAT TYPE) (13 CORE)

66
106
0 108
152
0 229

1-417-656-11
1-500-497-11
1-827-226-31
1-832-798-21
8-820-244-01

MECHA DECK (CWN42FF601)

FILTER, CLAMP (FERRITE CORE)
CORD, POWER
CABLE, FLEXIBLE FLAT (5 CORE)
OPTICAL PICK-UP KSM-215DCP/C2NP

230
0 F1100
M741
M751
M891

1-471-035-21
1-532-506-33
A-1108-965-A
A-1108-966-A
1-763-072-11

MAGNET ASSY
FUSE (T6.3AL/250V)
MOTOR ASSY, TABLE (TABLE)
MOTOR ASSY, LOADING (LOADING)
FAN, DC

S711

86

1-477-680-12 ENCODER, ROTARY

Remarks

Ref. No.

Part No.

Description

Remarks

HCD-GNX660

REVISION HISTORY
Clicking the version allows you to jump to the revised page.
Also, clicking the version at the top of the revised page allows you to jump to the next revised page.

Ver.

Date

Description of Revision

1.0

2006.04

New

1.1

2006.10

Change of CN590 (Main board).

(ECB-62427)

Change of C301,302, R585 and 587 (Main board).

(ECB-63860)

Change of R1421 (MIC board).

(ECB-64469)

Change of S1306 (Switch board).

(ECB-67927)

Change of C528, 529, 629, R532, 552 and 652 (SMASTER board).
(ECB-70769)

1.2

2007.12

Change of R515, 615 and 802 (SMASTER board).

(ECB-70967)

Change of R1416 and 1417 (MIC board).

(ECB-79325)

Change of IC401 microprocessor (Main board).

(ECB-80690)

Change of C535, 550 and 582 (Main board).

(ECB-82670)

Suffix change of Main, Panel and Power combined board from -12 to -13.
Suffix change of SMASTER combined board from -12 to -13 or -21.
(SPM-07044)