HCD-GRX70 (9-928-843-11) PDF

HCD-GRX70/GRX70J/RXD80
SERVICE MANUAL
Canadian Model
HCD-RXD80
E Model
HCD-GRX70/GRX70J
Australian Model
HCD-GRX70
HCD-GRX70/GRX70J/RXD80 are the Amplifier, CD player, Tape Deck and Tuner

section in HMC-GRX70/GRX70J/RXD80.
Photo: HCD-GRX70 (GRAY)
Dolby noise reduction manufactured under license

from Dolby Laboratories Licensing Corporation.
DOLBY and the double-D symbol a are trademarks of Dolby Laboratories Licensing Corporation.
CD
Section
Model Name Using Similar Mechanism
HCD-GRX50/RXD7
CD Mechanism Type
CDM38LH-5BD32L
Base Unit Name
BU-5BD32L
Optical Pick-up Name

Tape deck
Section
KSS-213D/Q-NP
Model Name Using Similar Mechanism

Tape Transport Mechanism Type
HCD-GRX50/RXD7
TCM-230AWR2
SPECIFICATIONS
Amplifier section
Canadian model:
Continuous RMS power output (reference)
100 + 100 watts
(8 ohms at 1 kHz, 10% THD)
Total harmonic distortion less than 0.07%
(8 ohms at 1 kHz, 55 W)
Other models:
The following measured at AC 120, 220, 240 V 50/60 Hz
DIN power output (rated)
130 + 130 watts
(6 ohms at 1 kHz, DIN)
Continuous RMS power output (reference)
170 + 170 watts
(6 ohms at 1 kHz, 10% THD)
Inputs
MD/VIDEO (AUDIO) IN:
(phono jacks)
MIX MIC: (phone jack)
voltage 450 mV/250 mV,

impedance 47 kilohms
sensitivity 1 mV, impedance 10
kilohms
Outputs
MD OUT:
voltage 250 mV,
(phono jacks)
impedance 1 kilohms
PHONES:
accepts headphones of 8 ohms
(stereo mini jack)
or more
SPEAKER:
Canadian model:
accepts impedance of 8 to 16 ohms
SURROUND SPEAKER (GRX70/GRX70J):
accepts impedance of 16 ohms
SUPER WOOFER:
Voltage 1 V, impedance 1 kilohm
Continued on next page
MINI Hi-Fi COMPONENT SYSTEM

MICROFILM
Specifications (continued)
CD player section
System
Laser
Laser output
Compact disc and digital audio system

Semiconductor laser (=780nm)
Emission duration: continuous
Max. 44.6 W*
*This output is the value measured at
distance of 200 mm from the objective
lens surface on the Optical Pick-up
Block with 7 mm aperture.
2 Hz - 20 kHz (0.5 dB)
780 -790 nm
More than 90 dB
More than 90 dB
Frequency response
Wavelength
Signal-to-noise ratio
Dynamic range
CD OPTICAL DIGITAL OUT
(Square optical connector jack, rear panel)
Wavelength
600 nm
Output Level
-18 dBm
Tape player section
Recording system
Frequency response
(DOLBY NR OFF)
4-track 2-channel stereo

40 - 13,000 Hz (3 dB),
using Sony TYPE I cassette
40 - 14,000 Hz (3 dB),
using Sony TYPE II cassette
General
Power requirements
Canadian model:
Mexican model:
Australian model:
Thai model:
Other models:
120 V AC, 60 Hz
120 V AC, 50/60 Hz
230 - 240 V AC, 50/60 Hz
220 V AC, 50/60 Hz
120 V, 220 V, or 230 - 240 V AC,
50/60 Hz
Adjustable with voltage selector
Power consumption
170 watts
Dimensions (w/h/d)
Approx. 280 340 395 mm

(111/8 131/2 155/8 in.)
Mass
Canadian model:
Other models:
Supplied accessories:
Approx. 10.2 kg
Approx. 10.6 kg
AM loop antenna (1)
Remote Commander (1)
Batteries (2)
FM lead antenna (1)
Speaker cords (2)
Front speaker pads (8)
Design and specifications are subject to change without notice.
Tuner section
FM stereo, FM/AM superheterodyne tuner
FM tuner section
Tuning range
Antenna
Antenna terminals
Intermediate frequency
87.5 - 108.0 MHz

FM lead antenna
75 ohm unbalanced
10.7 MHz
UKV tuner section (3 band (FM-AM-UKV) models only)

Tuning range
65.0 - 74.0 MHz
Stereo Plus
AM tuner section
Tuning range
2 Band type:
Canadian model:
530 - 1,710 kHz
(with the interval set at 10 kHz)
531 - 1,710 kHz
Other models:
531 - 1,602 kHz
530 - 1,710 kHz
3 Band type:
Middle Eastern models:
MW:
531 - 1,602 kHz
SW:
5.95 - 17.90 MHz
Other models:
MW:
531 - 1,602 kHz
530 - 1,710 kHz
SW:
5.95 - 17.90 MHz
Antenna
AM loop antenna
Antenna terminals
External antenna terminal
Intermediate frequency
450 kHz
SAFETY-RELATED COMPONENT WARNING!!

COMPONENTS IDENTIFIED BY MARK ! OR DOTTED
LINE WITH MARK ! ON THE SCHEMATIC DIAGRAMS
AND IN THE PARTS LIST ARE CRITICAL TO SAFE
OPERATION. REPLACE THESE COMPONENTS WITH
SONY PARTS WHOSE PART NUMBERS APPEAR AS
SHOWN IN THIS MANUAL OR IN SUPPLEMENTS PUBLISHED BY SONY.
ATTENTION AU COMPOSANT AYANT RAPPORT
LA SCURIT!
LES COMPOSANTS IDENTIFIS PAR UNE MARQUE !
SUR LES DIAGRAMMES SCHMATIQUES ET LA LISTE
DES PICES SONT CRITIQUES POUR LA SCURIT
DE FONCTIONNEMENT. NE REMPLACER CES COMPOSANTS QUE PAR DES PICES SONY DONT LES
NUMROS SONT DONNS DANS CE MANUEL OU
DANS LES SUPPLMENTS PUBLIS PAR SONY.
SECTION 1
SERVICING NOTES
TABLE OF CONTENTS
1.
SERVICING NOTES ............................................... 3
2.
GENERAL
NOTES ON HANDLING THE OPTICAL PICK-UP

BLOCK OR BASE UNIT
3.
DISASSEMBLY ......................................................... 8
4.
TEST MODE .............................................................. 11
5.
MECHANICAL ADJUSTMENTS ....................... 14
The laser diode in the optical pick-up block may suffer electrostatic break-down because of the potential difference generated
by the charged electrostatic load, etc. on clothing and the human
body.
During repair, pay attention to electrostatic break-down and also
use the procedure in the printed matter which is included in the
repair parts.
The flexible board is easily damaged and should be handled with
care.
6.
ELECTRICAL ADJUSTMENTS
NOTES ON LASER DIODE EMISSION CHECK
Location of Controls ....................................................... 6

Setting the Time .............................................................. 7
DECK Section ................................................................. 14

CD Section ...................................................................... 17
7.
DIAGRAMS
7-1.
7-2.
7-3.
7-4.
7-25.
Block Diagram CD SERVO Section ........................

Block Diagram TAPE DECK Section ......................
Block Diagram MAIN Section .................................
Block Diagram DISPLAY/KEY CONTROL/
POWER SUPPLY Section ...........................................
Note for Printed Wiring Boards and
Schematic Diagrams .......................................................
Printed Wiring Board BD Board ..............................
Schematic Diagram BD Board ................................
Printed Wiring Boards CD MOTOR Section ..........
Schematic Diagram CD MOTOR Section ..............
Printed Wiring Board AUDIO Board ......................
Schematic Diagram AUDIO Board .........................
Printed Wiring Board LEAF SW Board ..................
Schematic Diagram LEAF SW Board .....................
Printed Wiring Board MAIN Board ........................
Schematic Diagram MAIN Board (1/4) .................
Schematic Diagram MAIN Board (2/4) ..................
Printed Wiring Board PANEL Board ......................
Schematic Diagram PANEL Board .........................
Printed Wiring Board CD SW Board ......................
Schematic Diagram CD SW Board .........................
Printed Wiring Boards
TRANSFORMER Section ........................................
Schematic Diagram
TRANSFORMER Section ........................................
IC Pin Function Description ...........................................
8.
EXPLODED VIEWS ................................................ 72
9.
ELECTRICAL PARTS LIST ............................... 81
7-5.
7-6.
7-7.
7-8.
7-9.
7-10.
7-11.
7-12.
7-13.
7-14.
7-15.
7-16.
7-17.
7-18.
7-19.
7-20.
7-21.
7-22.
7-23.
7-24.
19
21
23
25
27
29
31
33
35
37
39
41
41
43
45
47
49
51
53
55
57
58
61
The laser beam on this model is concentrated so as to be focused

on the disc reflective surface by the objective lens in the optical
pick-up block. Therefore, when checking the laser diode emission, observe from more than 30 cm away from the objective lens.
Notes on chip component replacement
Never reuse a disconnected chip component.
Notice that the minus side of a tantalum capacitor may be damaged by heat.
Flexible Circuit Board Repairing
Keep the temperature of the soldering iron around 270 C during repairing.
Do not touch the soldering iron on the same conductor of the
circuit board (within 3 times).
Be careful not to apply force on the conductor when soldering
or unsoldering.
CAUTION
Use of controls or adjustments or performance of procedures
other than those specified herein may result in hazardous radiation exposure.
This appliance is classified as a CLASS 1 LASER product.

The CLASS 1 LASER PRODUCT MARKING is located on
the rear exterior.
63
67
Laser component in this product is capable of emitting radiation

exceeding the limit for Class 1.
The following caution label is located inside the unit.
CAUTION : INVISIBLE LASER RADIATION WHEN
INTERLOCKS DEFEATED. AVOID EXPOSURE TO BEAM.
OPEN
AND
ADVARSEL :
USYNLIG LASERSTRLING VED BNING NR

SIKKERHEDSAFBRYDERE ER UDE AF FUNKTION. UNDG UDSAETTELSE
FOR STRLING.
VORSICHT : UNSICHTBARE LASERSTRAHLUNG, WENN

ABDECKUNG GEFFNET UND SICHEREITSVERRIEGELUNG
BERBRCKT. NICHT DEM STRAHL AUSSETZEN.
VARO !
: AVATTAESSA JA SUOJALUKITUS OHITETTAESSA OLET ALTTIINA NKYMTTMLLE LASERSTEILYLLE. L KATSO STEESEEN.
VARNING : OSYNLING LASERSTRLING NR DENNA DEL R PPNAD
OCH SPRREN R URKOPPLAD. BETRAKTA EJ STRLEN.
ADVERSEL : USYNLIG LASERSTRLING NR DEKSEL PNES OG
SIKKERHEDSLS BRYTES. UNNG EKSPONERING FOR STRLEN.
VIGYAZAT ! : A BURKOLAT NYITSAKOR LTHATATLAN LZERSUGRVESZLY! KERLJE A BESUGRZST!
MODEL IDENTIFICATION
Rear Panel
PART No.
MODEL
PART No.
Thai model
4-214-456-6
Argentine and 120 V AC Area in E models
4-215-169-0
Singapore model
4-215-169-1
Mexican model
4-215-169-2
Saudi Arabia model
4-215-169-3
GRX70J: 240 V AC Area in E model
4-215-169-5
Canadian model
4-219-987-0
GRX70: 240 V AC Area in E model
4-219-987-2
Taiwan model
4-219-987-3
Australian model
4-219-987-4
HOW TO OPEN THE DISC TRAY WHEN POWER SWITCH TURNS OFF.
1 Remove the Case.
3 Pull-out the disc tray.

2 Turn the cam to the
direction of arrow.
NOTE FOR INSTALLATION (ROTARY ENCODER)

Note:When attaching the Base unit, Insert the
section A into the groove of BU cam.
BU cam
Section A
Groove
Note:When attaching the BU cam,

engage the Rotary encoder
switch as shown in the figure.
SECTION 2
GENERAL
This section is extracted from

instruction manual.
LOCATION OF CONTOROLS
Front Panel
@ EDIT, DIRECTION, TUNER MEMORY

button
PLAY MODE, DOLBY NR button
REPEAT, STEREO/MONO button
# EFFECT button
FILE SELECT button
GEQ CONTROL button
P FILE MEMORY button
# FUNCTION button
Rear Panel
1 CD DIGITAL OUT terminal
2 VIDEO (AUDIO) IN jack
3 FM ANTENNA terminal
4 MD IN/OUT jack
5 SUPER WOOFER jack
6 SURROUND SPEAKER terminal (GRX70/GRX70J)
7 SPEAKER terminal
8 AM ANTENNA terminal
9 VOLTAGE SELECTOR switch
(GRX70: 120 V AC Area in E, 240 V AC Area in E, Saudi
Arabia, Singapore, Taiwan, Argentine models)
SECTION 3
DISASSEMBLY
Note: Follow the disassembly procedure in the numerical order given.
COVER
6 cover
2 screw
(case 3TP2) (3 12)
1 three screws
(BVTP3 8)
3 two screws
(case 3TP2) (3 8)
2 screw
(case 3TP2) (3 12)
5
4
LOADING PANEL ASSY

3 loading panel assy
A
1 Turn the cam-in the
direction of the arrow A.
2 Pull-out
the disc tray.
3 two screws
(case 3TP2) (3 8)
FRONT PANEL SECTION
1 wire (flat type)

(15 core) (32 cm) (CN303)
4 screw
(BVTT3 10)
3 lug
2 screw
(BVTT3 6)
6 front panel section
3 lug
4 screw
(BVTP3 10)
2 screw
(BVTT3 6)
1 wire (flat type)

(23 core) (CN501)
1 wire (flat type) (17 core)
(CN304)
5 two screws
(BVTT3 6)
CD MECHANISM DECK SECTION (CDM38LH-5BD32L)

3 Remove the CD mechanism
deck (CDM38LH-5BD32L)
in the direction of arrows
A B.
B
2 two screws
(BVTP3 8)
1 screw
(BVTP3 10)
5 wire (flat type) (19 core)

(CN391)
4 two connectors
(CN392, 393)
1 screw
(BVTP3 10)
TAPE MECHANISM DECK SECTION (TCM-230AWR2)

3 three screws
(BVTP2.6 8)
3 two screws
(BVTP2.6 8)
2 Open two
cassette lids.
4 tape mechanism deck section

(TCM-230AWR2)
1 Push the cassette lid.
1 Push the cassette lid.
MAIN BOARD
Abbreviation
AR : Argentine model
AUS : Australian model
E2 : 120 V AC Area in E model
MX : Mexican model
SP : Singapore model
TH : Thai model
TW : Taiwan model
1 wire (flat type)

13 core: GRX70: E2, TH, MX, AR, AUS/RXD80
15 core: GRX70: E3, SP, TW/GRX70J
(CN371)
5 five screws
(BVTP3 8)
3 two screws
(BVTP3 8)
5 screw
(BVTP3 8)
(GRX70/GRX70J)
2 connector
(CN953) (GRX70/GRX70J)
2 connector
(CN952)
7 connector
(CN403)
4 two screws
(BVTP3 8)
6 Remove the MAIN board

in the direction of the arrow.
10
SECTION 4
TEST MODE
[MC Cold Reset]
The cold reset clears all data including preset data stored in the
RAM to initial conditions. Execute this mode when returning
the set to the customer.
Procedure:
1. Turn the power ON or set to the DEMO mode.
2. Press three buttons of p , [ENTER/NEXT], and 1/u simultaneously.
3. The set is reset, and displays COLD RESET, then becomes
DEMO mode.
[MC Hot Reset]
This mode resets the set with the preset data kept stored in the
memory. The hot reset mode functions same as if the power
cord is plugged in and out.
Procedure:
1. Turn the power ON or set to the DEMO mode.
2. Press three buttons of p , [ENTER/NEXT], and [DISC1] simultaneously.
3. The set is reset, and becomes standby state.
[CD Service Mode]

This mode can run the CD sled motor optionally. Use this mode,
for instance, when cleaning the optical pick-up.
Procedure:
1. Press the 1/u button to turn the power ON.
2. Select the function CD.
3. Press three buttons of p , [ENTER/NEXT], and simultaneously.
4. Set to the Sled Servo mode.
5. With the CD in stop status, turn the JOG dial clockwise to
move the optical pick-up to outside track, or turn it counterclockwise to inside track.
6. To exit from this mode, perform as follows.
1) Move the optical pick-up to the most inside track.
2) Disconnect the power cord.
Notes: Always move the optical pick-up to most inside track when
exiting from this mode. Otherwise, a disc will not be unloaded.
Do not run the sled motor excessively, otherwise the gear can
be chipped.
[Change-over the AM Tuning Interval]

(EXCEPT Saudi Arabia model)
The AM tuning interval can be changed over 9 kHz or 10 kHz.
Procedure:
2. Select the function TUNER, and press the [TUNER/BAND]
button to select the BAND AM.
3. Press the 1/u button to turn the power OFF.
4. Press the [ENTER/NEXT] and 1/u buttons simultaneously,
and the display on the fluorescent indicator tube changes to
AM 9 k STEP or AM 10 k STEP, and thus the tuning
interval is changed over.
[CD Delivery Mode]
This mode moves the optical pick-up to the position durable to
vibration. Use this mode when returning the set to the customer
after repair.
Procedure:
2. Press the [LOOP] and 1/u buttons simultaneously.
3. A message LOCK is displayed on the fluorescent indicator
tube, and the CD delivery mode is set.
[LED and Fluorescent Indicator Tube All Lit, Key Check
Mode]
Procedure:
1. Press three buttons of p , [ENTER/NEXT], and [DISC2] simultaneously.
2. LEDs and fluorescent indicator tube are all turned on.
Press the [DISC2] button, and the key check mode is activated.
3. In the key check mode, the fluorescent indicator tube displays
K 0 J0 V0. Each time a button is pressed, K value increases. However, once a button is pressed, it is no longer taken
into account.
J value increases like 1, 2, 3 ... if turn the JOG dial clockwise, or it decreases like 0, 9, 8 ... if turn the JOG dial counterclockwise.
V value increases like 1, 2, 3 ... if turn the [VOLUME] dial
clockwise, or it decreases like 0, 9, 8 ... if turn the JOG dial
counterclockwise.
4. To exit from this mode, press three buttons in the same manner as step 1, or disconnect the power cord.
11
[Aging Mode]
This mode can be used for operation check of CD section and tape
deck section.
CD section and tape deck section work in parallel.
If an error occurred:
The aging operation stops only an error occurred sections and
display then status.
If no error occurs:
The aging operation continues repeatedly.
Procedure:
1. Set disc in DISC1 tray.
2. Load the tapes into the decks A and B respectively.
3. Press the [PLAYMODE] button to set the ALL DISCS mode,
and press the [REPEAT] button to REPEAT off.
4. Press the [FUNCTION] button to select the function CD.
5. Press three buttons of p , [ENTER/NEXT], and [DISCSKIP/
EX-CHANGE] simultaneously.
6. The aging mode is activated, if the indicator of disc tray number on the fluorescent indicator tube is blinking.
7. To exit from the aging mode, press the 1/u button to turn the
power OFF and operate the cold reset. (Refer to the MC Cold
Reset)
1. Display at the Aging Mode
Display operating state of CD section and tape deck section alternately.
If an error occurred, stop display which that section.
2. CD Section
Display at the aging mode is the same as the normal operation.
The sequence during the aging mode is following as below.
Aging mode sequence (CD section) :
Turn the disc tray
Display at an error occurred

1) Display of the error count
(1) Press three buttons of p , [ENTER/NEXT], and [CDSYNC]
simultaneously.
(2) Display of the error count following as below.
Display
EMC**EDC**
Notes:
EMC**: The number of mechanical error.
EDC** : The number of no disc error after chucking the disc.
2) Display of mechanical error

Display
E**M##$$&&
Notes:
** : The number of mechanical error.(00 is latest one)
(Press the [PLAYMODE] button to changes next error display)
## : Not used.
$$ : Loading error. (Second figure is not used)
D : The error in the midst of close at the except mechanical trouble.
E : The error in the midst of open at the except mechanical trouble.
C : The error in the midst of chuck up at the except mechanical
trouble.
F : The error in the midst of EX-open at the except mechanical
trouble.
&&: Loading error. (Second figure in not used)
1:The error in the midst of chuck up.
2:The error in the midst of chuck down.
3:Time up of EX-open
4:Time up of EX-close.
3) Display of no disc error

Disc1 chucking
Display
E**D##$$&&
TOC read
Play track1 for 2 seconds
Play last track for 2 seconds
Notes:
** : The number of mechanical error.(00 is latest one)
(Press the [REPEAT] button to changes next error display)
##:
01: Focus error
02: GFS error
03: Set up error
$$:
00: No disc error when does not chucking retry.
02: No disc error when chucking retry to completion.
&&: The state when judged no disc error. (Second figure is not used)
1:Stop
2:Set up
3:TOC read
4:Access
5:Play
6:Pause
7:Manual search (Play)
8:Manual search (Pause)
12
3. Tape Deck Section

The sequence during the aging mode is following as below.
If an error occurred, stop display that step.
Aging mode sequence (Tape deck section) :
Rewind the tape A and B

TAPE A AG-1
Shut off
FWD play the tape A
TAPE A AG-2
2 minutes
Fast forward the tape A
TAPE A AG-3
Shut off or 20 seconds
REV play the tape A
TAPE A AG-4
2 minutes
Rewind the tape A
TAPE A AG-5
Shut off
FWD play the tape B
TAPE B AG-2
2 minutes
Fast forward the tape B
TAPE B AG-3
Shut off or 20 seconds
REV play the tape B
TAPE A AG-4
2 minutes
Rewind the tape B
TAPE B AG-5
Shut off
Note: TAPE * AG-* is display of each step.
13
SECTION 6
ELECTRICAL ADJUSTMENTS
SECTION 5
MECHANICAL ADJUSTMENTS
Precaution
1. Clean the following parts with a denatured alcohol-moistened
swab:
record/playback heads
pinch rollers
erase head
rubber belts
capstan
idlers
2. Demagnetize the record/playback head with a head demagnetizer.
3. Do not use a magnetized screwdriver for the adjustments.
4. After the adjustments, apply suitable locking compound to the
parts adjusted.
5. The adjustments should be performed with the rated power supply voltage unless otherwise noted.
Torque Measurement
Mode
Torque meter
Meter reading
FWD
CQ-102C
31 to 71 g cm
(0.43 0.98 oz inch)
FWD
back tension
CQ-102C
2 to 6 g cm
(0.03 0.08 oz inch)
REV
CQ-102RC
31 to 71 g cm
(0.43 0.98 oz inch)
REV
back tension
CQ-102RC
2 to 6 g cm
(0.03 0.08 oz inch)
FF/REW
CQ-201B
71 to 143 g cm
(0.99 1.99 oz inch)
FWD tension
CQ-403A
100 g or more
(3.53 oz or more)
REV tension
CQ-403R
100 g or more
(3.53 oz or more)
DECK SECTION
0 dB=0.775 V
1. Demagnetize the record/playback head with a head demagnetizer.

2. Do not use a magnetized screwdriver for the adjustments.
parts adjust.
4. The adjustments should be performed with the rated power
supply voltage unless otherwise noted.
5. The adjustments should be performed in the order given in
this service manual. (As a general rule, playback circuit adjustment should be completed before performing recording
circuit adjustment.)
6. The adjustments should be performed for both L-CH and RCH.
7. Switches and controls should be set as follows unless otherwise specified.
8. Set to the DOLBY NR OFF.
9. Set to the test mode.
(1) Press the 1/u button to turn the power ON.
(2) Select the function TAPE A or B.
(3) Press the button of p , [ENTER/NEXT], and [DISC3]
simultaneously, to set the tape deck test mode and blink
the indicator of disc tray number on the fluorescent indicator tube.
(4) To exit from the test mode, press the 1/u button.
Test Tape
Tape
Signal
Used for
P-4-A100
10 kHz, 10 dB
Azimuth Adjustment
WS-48B
3 kHz, 0 dB
Tape Speed Adjustment
P-4-L300
315 Hz, 0 dB
Level Adjustment
Record/Playback Head Azimuth Adjustment
DECK A
DECK B
Note: Perform this adjustments for both decks
Procedure:
1. Mode: Playback
test tape
P-4-A100
(10 kHz, 10 dB)
main board
MD OUT jack (J101)
L-CH, R-CH
level meter
set
14
2. Turn the adjustment screw and check output peaks. If the peaks
do not match for L-CH and R-CH, turn the adjustment screw
so that outputs match within 1dB of peak.
frequency counter
+
set
within
1dB
Output
level
R-CH
peak
L-CH
peak
main board
MD OUT jack (J101)
L-CH, R-CH
1. Insert the WS-48B into the deck B.

2. Press the ( button on the deck B.
3. Press the [HI-DUB] button in playback mode.
Then at HIGH speed mode.
4. Adjust RV1001 on the LEAF SW board do that frequency
counter reads 6,000 180 Hz.
5. Press the [HI-DUB] button.
Then back to NORMAL speed mode.
6. Adjust RV1002 on the LEAF SW board so that frequency
counter reads 3,000 90 Hz.
Screw
position
R-CH
peak
3. Mode: Playback
test tape
P-4-A100
(10 kHz, 10 dB)
L-CH
main board
MD OUT jack (J101)
L-CH
oscilloscope
MAIN
board
CN301
set
Adjustment Location: LEAF SW board

Sample value of Wow and Flutter: 0.3% or less W.RMS (JIS)
(WS-48B)
R-CH
Playback level Adjustment

Procedure:
Mode: Playback
R-CH
waveform of oscilloscope
in phase 45
good
DECK B
test tape
WS-48B
(3 kHz, 0 dB)
within
1dB
L-CH
peak
Screw
position
Tape Speed Adjustment

Mode: Playback
DECK A
test tape
P-4-L300
(315 Hz, 0 dB)
90 135 180
wrong
level meter
set
main board
MD OUT jack (J101)
L-CH, R-CH
4. Repeat step 1 to 3 in playback (REV) mode.

pats adjusted.
Adjustment Location: Playback Head (Deck A).
Record/Playback/Erase Head (Deck B).
DECK B
Deck A is RV311 (L-CH) and RV411 (R-CH), Deck B is RV301

(L-CH) and RV401 (R-CH) so that adjustment within adjustment
level as follows.
Adjustment Level:
J101 PB level: 301.5 to 338.3 mV (8.2 to 7.2 dB) level
difference between the channels: within 0.5 dB
Adjustment Location: AUDIO board
forward
reverse
15
REC Bias Adjustment DECK B

Procedure:
1. Mode: Record
FUNCTION: VIDEO
AF OSC
Specification values:
J101 PB level: 47.2 to 53.0 mV (24.3 to 23.3 dB)
Adjustment Location: MAIN board
main board
VIDEO (AUDIO) IN jack (J101)
L-CH, R-CH
1) 315 Hz
50 mV (23.8 dB)
2) 10 kHz
attenuator
600
MAIN BOARD (Conductor Side)
RV301
L
IC301
blank tape
CN-123
REC LEVEL
VIDEO (AUDIO) IN
(L/R)
RV351
R
set
J101
MD OUT
(L/R)
2. Mode: Playback
recorded
portion
level meter
+
set
main board
MD OUT jack (J101)
L-CH, R-CH
3. Confirm playback the signal recorded in step 1 become specification values as follows.
If these values are out of specification values, adjust the RV341
(L-CH) and RV441 (R-CH) on the AUDIO board to repeat
steps 1and 2.
AUDIO BOARD (Component Side)
RV441
RV401
PB LEVEL
DECK A
TAPE SPEED
(NORMAL) (HIGH)
blank tape
CS-123
600
attenuator
set
2. Mode: Playback
level meter
+
main board
MD OUT jack (J101)
L-CH, R-CH
3. Confirm playback the signal recorded in step 1 become specification values as follows.
If these values are out of specification values, adjust the RV301
(L-CH) and RV351 (R-CH) on the MAIN board to repeat steps
1 and 2.
16
RV1002
RV1001
LEAF SW BOARD (Component Side)
main board
VIDEO (AUDIO) IN jack (J101)
L-CH, R-CH
315 Hz, 50 mV (23.8 dB)
set
RV311 RV411
R L
PB LEVEL REC BIAS

DECK B
REC Level Adjustment DECK B

Procedure:
1. Mode: Record
FUNCTION: VIDEO
recorded
portion
CN601
RV341
Specification values: Playback output of 315 Hz to playback

output of 10 kHz: 0.5 dB
Adjustment Location: AUDIO board
AF OSC
IC602
RV301
CN1001
E-F Balance (1 Track Jump) Check
CD SECTION
oscilloscope
Note:
1. CD Block is basically designed to operate without adjustment. Therefore, check each item in order given.
2. Use YEDS-18 disc (3-702-101-01) unless otherwise indicated.
3. Use an oscilloscope with more than 10 M impedance.
4. Clean the object lens by an applicator with neutral detergent when the
signal level is low than specified value with the following checks.
TP (TE)
TP (VC)
Procedure :
1. Connect oscilloscpe to TP (TE) and TP (VC).
2. Turn the power ON.
3. Load a disc (YEDS-18) and playback the number five track.
4. Press the ^ (CD) button. (Becomes the 1 track jump mode)
5. Confirm that the level B and A (DC voltage) on the oscilloscope waveform.
S-Curve Check
oscilloscope
BD board
TP (FE)
TP (VC)
BD board
Procedure:
1. Connect oscilloscope to TP (FE).
2. Connect between TP (FE1) and TP (VC) by lead wire.
3. Connect between TP (AGCCON) and TP (GND) by lead wire.
5. Load a disc (YEDS-18) and actuate the focus search. (In consequence of open and close the disc tray, actuate the focus
search)
6. Cofirm that the oscilloscope waveform (S-curve) is symmetrical between A and B. And confirm peak to peak level within
4 1 Vp-p.
1 track jump waveform
center of
waveform
B
A (DC voltage)
0V
level = 1.3 0.6 Vp-p
Specified level:
S-curve waveform
symmetry
A
100 = less than 22%
B
symmetry
6. After check, remove the lead wire connected in step 1.

A
within 4 1 Vp-p
7. After check, remove the lead wire connected in step 2 and 3.

Note: Try to measure several times to make sure than the ratio of A : B
or B : A is more than 10 : 7.
Take sweep time as long as possible and light up the brightness
to obtain best waveform.
RF Level Check
oscilloscope
BD board
TP (TE)
TP (VC)
Procedure:
1. Connect oscilloscope to TP (RF).
2. Connect between TP (AGCCON) and TP (GND) by lead wire.
4. Load a disc (YEDS-18) and playback.
5. Confirm that the oscilloscope waveform is clear and check RF
signal level is correct or not.
6. After check, remove the lead wire connected in step 2.
Note: Clear RF signal waveform means that the shape can be clearly
distinguished at the center of the waveform.
VOLT/DIV: 200 mV
TIME/DIV: 500 ns
level:
1.45 0.3 Vp-p
17
Checking Location:
BD BOARD (Side B)
TP (GND)
TP (VC)
IC102
TP (RF)
IC103
TP
(AGCCON)
TP (FE)
TP (TE)
TP (FE1)
18
SECTION 7
DIAGRAMS
BLOCK DIAGRAM CD SERVO Section
55
16K
RAM
7
A
4
B
2
C
D
I-V AMP
F
10
10
E
6
11
RF
SUMMING
AMP
RF EQ RFO
16
AMP
51
49
48
D
FOCUS
ERROR AMP
FE
TRACKING
ERROR AMP
TE
RFAC
ASYMMETRY
CORRECTION
EFM
DEMODULATOR
DIGITAL
PLL
ASYI
D/A
INTERFACE
INTERNAL BUS
56 53
PCO
CD D+5V
54
DIGITAL SIGNAL PROCESSOR,

DIGITAL FILTER, D/A CONVERTER
IC101 (1/2)
FILI
RF AMP,
FOCUS/TRACKING ERROR AMP
IC103
CLTV
DETECTOR
FILTER
FILO
7-1.
PCMD
62
BCK
63
LRCK
61
C2PO
19
ASYO
14
SERIAL
IN
INTERFACE
ERROR
CORRECTOR
E I-V AMP
SUBCODE
PROCESSOR
DIGITAL
CLV
13
26
LDON
LASER DIODE
LD
LD
APC LD
AMP
PD
APC PD
AMP
SERVO AUTO
SEQUENCER
14
5 6 7
AOUT2
70
71
77
SERVO
INTERFACE
76
LOUT1
AIN1
AIN2
BUFFER
LOUT2
CD-L
72
75
20
CLOCK
GENERATOR
1 2
XTAO
R-CH
66
67
DOUT
EMPH
WFCK
GFS
SCLK
COUT
SSTP
9 21 27
XTAI
TIMING
LOGIC
64 15 18
X101
16.9344MHz
60
IC381
22
CD DIGITALOUT
OPTICAL
S101
(LIMIT)
OPTICAL
TRANSCEIVER
IC381
ON : When the optical pick-up

is inner position.
FOCUS/TRACKING COIL DRIVE,

SPINDLE/SLED MOTOR DRIVE
IC102
33 SQ-CLK
32 SQ-DATA
DISC-SENS 60
DISC IN DETECT
SENSOR
IC703
LEVEL SHIFT
Q701
19 SCOR
M101
(SPINDLE)
15
16
CH4OUTF
CH4OUTR
MOTOR
DRIVE
CH4SIN
56 SENSE
25
37 CD-CLK
58 XLT
35 CD-DATA
DISC TRAY SENSOR

IC702
TBL-SENS 61
57 HOLD
S801
(OPEN/CLOSE DET)
CLOSE
18
CH3OUTR
MOTOR
DRIVE
CH3RIN
24
A/D
CONVERTER
23
28
(FOCUS) (TRACKING)
2-AXIS
DEVICE
29
12
11
CH2OUTF
CH2OUTR
CH2FIN
COIL
DRIVE
CH2RIN
30
31
32
33
14
13
CH1FIN
CH1OUTF
CH1OUTR
COIL
DRIVE
CH1RIN
OUT-OPEN 71
DIGITAL SERVO
PROCESSOR
IC101 (2/2)
SRDR
TFDR
TRDR
FFDR
FRDR
OPEN
SYSTEM CONTROLLER
(CD MECHANISM CONTROL)
IC501 (1/4)
ENC1 70
ENC2 69
ENC3 68
SFDR
FOCUS/TRACKING/SLED
SERVO DSP
17
FOCUS/TRACKING/SLED
PWM GENERATOR
CH3FIN
CH3OUTF
TE
FE
RFDC
SE
40 41 39 43
M102
(SLED)
A
(Page 23)
TO MIRR/DFCT/
FOK DETECTOR
DIGITAL
OUT
SQSO
SQCK
SCOR
SENS
XLON
DATA
XLAT
CLOK
21
XRST
MDP
HOLD SW
OPTICAL PICK-UP
(KSS-213D/Q-NP)
PD
AOUT1
F I-V AMP
CPU INTERFACE
AUTOMATIC
POWER
CONTROL
Q101
PWM
&
INTEGRATOR
DIGITAL
FILTER,
NOISE SHAPER
MIRR/DFCT/
FOK
DETECTOR
FOK
24
MIRR
22
DFCT
23
4
2
3
ROTARY
ENCODER
S811
DISC TRAY
ADDRESS DETECT
DISC TRAY SLIDE MOTOR DRIVE

IC801
LOAD-OUT 66
LOAD-IN
67
10
2
OUT1
FIN
RIN
MOTOR
DRIVE
OUT2
7
4
M801
(DISC TRAY SLIDE)
M701
(DISC TRAY TURN)
2
TO SERVO INTERFACE
3
MUTE 20
DISC TRAY TURN MOTOR DRIVE

IC701
59 XRST
05
TBL-L 63
TBL-R 65
3
6
IN1
IN2
MOTOR
DRIVE
OUT1
OUT2
7
2
SIGNAL PATH
: CD PLAY (ANALOG OUT)
: CD PLAY (DIGITAL OUT)
19
20
7-2.
BLOCK DIAGRAM TAPE DECK Section

DECK PROCESS
DECK A/B SELECT, PB/REC EQ AMP,
DOLBY NR AMP, ALC, AMS
IC301
SIGNAL PATH
: PLAYBACK (DECK A)
: PLAYBACK (DECK B)
: RECORD
DOLBY PASS
HP101
(PLAYBACK)
70
46
AIN (L)
BIN (L)
120
RV311
R-CH
PB LEVEL (L)
(DECK A)
R-CH
R-CH
L-CH
RV301
R-CH
PB LEVEL (L)
(DECK B)
R-CH
17 19 15 16 18 20 22 23 24 25
43 44
ALC
IN (L)
MAOUT
28
ROUT (L)
BIAS
CONTROL
CIRCUIT
ALC (L)
BUFFER
A 120/70
B NORM/CROM
ALC ON/OFF
PB A/B
NORM/HIGH
BIAS ON/OFF
RM ON/OFF
NR ON/OFF
REC/PB/PASS
LM ON/OFF
PB EQ AMP
(DECK B)
IC601
ALC
RIN (L)
33
32
31
HRPE101 (1/2)
(RECORD/PLAYBACK)
B
(Page 23)
+
L.P.F.
BIAS (N)
BIAS (C)
BIAS (M)
PB-L
40
DOLBY NR
AMP
CIRCUIT
35
34
EQ IN (L)
48
REC OUT (L)
PB EQ AMP
(DECK A)
IC611
L-CH
PB OUT (L)
39
REC
EQ AMP
EQ OUT
(L)
36
38
27
MSIN
RV301
AMS
CIRCUIT
REC LEVEL (L)

(DECK B)
MSOUT
REC-L
26
C
(Page 24)
REC/PB SWITCHING
IC602
S1004
(DECK A 120/70)
3
R-CH
R-CH
S1008
(DECK B 120/70)
2
C331, L331
BIAS
TRAP
72
76
A-TRG
B-TRG
CAP-M-H/L
85 84 83 82 81 80 79 78
77
91
90
B-SHUT
73
100
87
86
S1003
(DECK A HALF)
SYSTEM CONTROLLER
IC501 (2/4)
B-HALF
BIAS OSC
Q621, 622
TRIGGER
PLUNGER DRIVE
(DECK B)
Q331, 332
A-HALF
BIAS OSC
T621
HRPE101 (2/2)
(ERASE)
88
89
RV1002
TAPE SPEED
(NORMAL)
CAPSTAN MOTOR
CONTROL SWITCH
Q1001
TRIGGER
PLUNGER DRIVE
(DECK A)
Q333, 334
A-SHUT
B+
(A+7V)
TRIGGER PLUNGER
DECK B
ROTATION
DETECT SENSOR
(DECK B)
IC1002
AMS-IN
REC BIAS
SWITCH
Q623
TRIGGER PLUNGER
DECK A
ROTATION
DETECT SENSOR
(DECK A)
IC1001
ALC-ON/OFF
PB-A/B
EQ-H/N
BIAS
B-PLAY-SW
REC-MUTE
NR-ON/OFF
R/P-PASS
TC-MUTE
RV341
REC BIAS (L)
(DECK B)
A-PLAY-SW
RV441
REC BIAS (R)
(DECK B)
TC-RELAY
R-CH
RV1001
TAPE SPEED
(HIGH)
Q335
CAPM-CNT1 75
CAPM-CNT2 74
S1006
(DECK B HALF)
S1005
(DECK A REC)
D+5V
S1001
S1002
(DECK A PLAY) (DECK B PLAY)
S1009
(DECK B REC)
05
21
22
CAPSTAN
MOTOR DRIVE
Q336 343
M1
(CAPSTAN)
7-3.
REC-L
BLOCK DIAGRAM MAIN Section

(GRX70J: Saudi Arabia)
RV711
ECHO LEVEL
DIGITAL ECHO
IC711
MD OUT
J101 (2/2)
MIC AMP
IC712 (2/2)
R-CH
RV712
MIC LEVEL
58
J101 (1/2)
R-CH
REC B2
38, 39
33 32 34
TM402
37
+
L
INPUT SELECT SWITCH,

GRAPHIC EQUALIZER CONTROL,
ELECTRICAL VOLUME
IC101
MD IN
60 5
FEED BACK
SWITCH
Q112
R-CH
D141
59 6
R-CH
30
DBFB CONTROL
SWITCH
Q111
SPEANA
TM401
R-CH
SPEAKER
IMPEDANCE
USE 6 16
1
DBFB-H/L 7
BASS FREQ. 44
ANTENNA
FM
75
BASS FREQUENCY
CONTROL SWITCH
Q201
493-DATA 47
493-CLK 48
493-LATCH 38
R-CH
R-CH
FM ANT
ST-L
FM ANT
ST-R
AM ANT
ST-MUTE
STEREO
TUNED
49 ST-MUTE
50 STEREO
51 TUNED
ST-DIN
ST-DOUT
ST-CLK
ST-CE
53
54
55
52
AM ANT
R-CH
D644
FM/AM TUNER UNIT
AM
R-CH
D607
POWER AMP
IC801
R-CH
SYSTEM CONTROLLER
IC501 (3/4)
ST-DOUT
ST-DIN
ST-CLK
ST-CE
MUTING
Q113
R-CH
STK-MUTE
MUTING
Q411, 471
STANDBY SWITCH
Q803, 804, 881
TH831
J701
PHONES
TEMPERATURE
DETECT SWITCH
Q831, 832
MUTING CONTROL
SWITCH
Q412
1
+5V
MUTING CONTROL
SWITCH
Q508, 509
LINE-MUTE
OVER LOAD
DETECT
Q801
RESET SIGNAL
GENERATOR
IC502
AC-CUT 22
RESET 12
11 XC-OUT
: CD PLAY
X601
32.768kHz
: TAPE PLAY
: RECORD
: MIC INPUT
RESET SWITCH
Q501
D803
OVER LOAD
DETECT SWITCH
Q437
OVER LOAD
DETECT SWITCH
Q432
DC DETECT
SWITCH
Q433, 434
R-CH
PROTECTOR 27
10 XC-IN
13 X-OUT
+
R-CH
SIGNAL PATH
: TUNER (FM/AM)
F-RELAY
PROTECT SWITCH
Q439
PROTECT SWITCH
Q435, 436
X613
16MHz
15 X-IN
RY-SW 36
05
(Page 25)
SURROUND SPEAKER
IMPEDANCE USE 16
R-CH
(Page 25)
L+R
M501
(FAN)
FAN MOTOR
DRIVE
Q401, 402
CPU
INTERFACE
COMMAND
R-CH
SUPER
WOOFER
PROTECT
SWITCH
Q192
36
KEY OUT 2
KEY OUT 1
VIDEO
(AUDIO) IN
41
BUF
OUT2
BASS BOOST
CONTROL
CIRCUIT
VOLUME
CONTROL
MUTING
Q191
BUF IN2
SOUND
CONTROL
CIRCUIT
42
VOL
IN2
BB B2,
BB A2
INPUT
SELECT
SWITCH
F OUT2
LATCH
IN B2
IN A2
IN C2
J191
CLOCK
PB-L
IN E2
IN D2
72
D191
DATA
65
66
68
69
67
KEY IN2
KEY IN1
GRAPHIC EQUALIZER
CONTROL CIRCUIT
CD-L
SUPER
WOOFER
57
REC A2
MIC IN
(Page 22)
R-CH
MIC AMP
IC712 (1/2)
(Page 22)
J711
MIX MIC
(Page 20)
RESET
23
24
RY401
RELAY
DRIVE
Q431
BLOCK DIAGRAM DISPLAY/KEY CONTROL/POWER SUPPLY Section
G13 G18
46 67
32 27
GRID DRIVE
Q613
S LOW FREQ (BPF0) 16

BPF1 17
BPF2 18
BPF3 19
BPF4 20
ALL BAND (L+R) 21
(Page 23)
BAND-PASS FILTER
IC603
17
16
14
13
12
11
F01
F02
F04
F05
F06
L+R
DET
LINE
IN
B.P.F.
REC IN
DET
(RXD80)
SUB POWER TRANSFORMER

T11
RESET
SPEANA
(Page 23)
26V REGULATOR
Q13
+5V REGULATOR
IC11
RECT
D12 15
FL ON/OFF
SWITCH
Q12, 17
RECT
D17 20
FL ON/OFF
SWITCH
Q14 16
AC IN
RY11
G2 G12
44 42, 40 33
RELAY DRIVE
Q11
RESET 73
L SEL
7
POWER TRANSFORMER
T951
45 GR1
LED DRIVER
IC604
LED DATA
LED SCK
LED LAT
5
3
4
13 DATA
14 CLK
15 STB
11 14
KEY0 KEY3
S611 630,
S638 651, 751 757
(GRX70/GRX70J)
B+ SWITCH
Q601, 602
LED +5V
TO FLUORESCENT
INDICATOR TUBE
(FL601)
Q603
17, 19 23, 2, 3, 5, 7, 10, 11
FLUORESCENT INDICATOR TUBE

FL601
GRID DRIVE
Q607 612
S1 S22
FLUORESCENT INDICATOR TUBE DRIVER,

KEY CONTROL
IC601
P1 P6, P8, P9, P11, P12, P15, P16
7-4.
VF2
B+
D611 616, 619 622, 624,

D627 631, 751 753
RECT
D832
POWER AMP (IC801),

PROTECTOR CIRCUIT
B+
B
(RXD80)
GRX70: Thai, Mexican,

Australian/RXD80
26V
(FL DRIVER (IC601) B)
26V REGULATOR
Q971
RECT
D971
FL SW 42
SIRCS
(RXD80)
STBY RELAY 43
+5V
SYSTEM CONTROLLER
(IC501) B+
S601
(JOG DIAL)
ROTARY
ENCODER
S601
JOG-A
JOG-B
S602
VOLUME
ROTARY
ENCODER
S602
VOL-A
I2C DATA 78
10 VOL-B
I2C CLK 79
WAKE UP 22
+5V (STBY)
(PANEL SECTION B+)
30 IIC-DATA
D501, 502
D509
(GRX70/GRX70J)
+5V
REGULATOR
IC902
RECT
D901 904
(RXD80)
RECT
D907 910
29 IIC-CLK
CD D+5V, CD A+5V
CD MECHANISM DECK
SECTION B+
18 WAKE UP
CD-POWER
D925
(GRX70/GRX70J)
(RXD80)
D+5V
M62493FP (IC101),
CD SENSOR CIRCUIT B+
POWER
B+ SWITCH
Q907, 908
B+ SWITCH
Q904, 905
(GRX70/GRX70J)
(RXD80)
LED DRIVE
Q604, 605
D754
I/u
D+5V
(TAPE DECK SECTION B+)
+7V
+7V
REGULATOR
Q901, 902, 913
7V
7V
REGULATOR
Q914, 951, 952
TC, PANEL,
AUDIO
D923
STBY LED 39
REGULATOR
CONTROL SWITCH
Q903, 923
D922
FAN MOTOR B
D405 407
(GRX70/GRX70J)
(RXD80)
XOUT
XIN
05
TIMER LED 26
72
70
LED DRIVE
Q606
D924
(GRX70/GRX70J)
X601
12.5MHz
25
+7V
REGULATOR
IC901
CD M+7V
(CD MOTOR SECTION B+)
D632
TIMER SELECT
LED +5V
(PANEL SECTION B+)
AC IN
VOLTAGE
SELECTOR
S951
(RXD80)
1
GRX70/
GRX70J
RECT
D831
(GRX70/GRX70J)
SYSTEM CONTROLLER
IC501 (4/4)
REMOTE CONTROL
RECEIVER
IC602
VF1
TC M+12V
(TC MOTOR SECTION B+)
ST +10V
(FM/AM TUNER UNIT B+)
+10V
REGULATOR
Q909
+12V
REGULATOR
IC903
26
GRX70: E2, E3, Singapore, Hong Kong,

Taiwan, Argentine/GRX70J
7-5.
NOTE FOR PRINTED WIRING BOARDS AND SCHEMATIC DIAGRAMS
Note on Printed Wiring Board:

X : parts extracted from the component side.
Y : parts extracted from the conductor side.
p
: parts mounted on the conductor side.
: internal component.
b : Pattern from the side which enables seeing.
(The other layers' patterns are not indicated.)
Caution:
Pattern face side:
(Side B)
Parts face side:
(Side A)
Parts on the pattern face side seen from

the pattern face are indicated.
Parts on the parts face side seen from
the parts face are indicated.
Note on Schematic Diagram:

All capacitors are in F unless otherwise noted. pF: F
50 WV or less are not indicated except for electrolytics
and tantalums.
All resistors are in and 1/4 W or less unless otherwise
specified.
: internal component.
2 : nonflammable resistor.
5 : fusible resistor.
C : panel designation.
Note:
The components identified by mark ! or dotted
line with mark ! are critical for safety.
Replace only with part
number specified.
Indication of transisitor.
Q
B C
E
These are omitted.
Q
B
These are omitted.
Note:
Les composants identifis par
une marque ! sont critiques
pour la scurit.
Ne les remplacer que par une
pice portant le numro
spcifi.
U : B+ Line.
V : B Line.
H : adjustment for repair.
Voltages are taken with a VOM (Input impedance 10 M).
Voltage variations may be noted due to normal production tolerances.
Waveforms are taken with a oscilloscope.
Voltage variations may be noted due to normal production tolerances.
Circled numbers refer to waveforms.
Signal path.
F : TUNER (FM/AM)
E : PLAYBACK (DECK A)
d : PLAYBACK (DECK B)
G : RECORD
J : CD PLAY (ANALOG OUT)
c : CD PLAY (DIGITAL OUT)
N : MIC INPUT
Abbreviation
AR
: Argentine model
CND : Canadian model
E2
: 120 V AC Area in E model
E3
EA3 : Saudi Arabia model
MX
: Mexican model
SP
: Singapore model
TH
: Thai model
TW : Taiwan model
Circuit Boards Location

Abbreviation
MX : Mexican model
TH : Thai model
TW : Taiwan model
TRANS board
SUB TRANS board

(RXD80)
TUNER PACK
(GRX70: MX, AR/RXD80)
TUNER (FM/AM)
(GRX70: E2, TH, AUS)
TUNER (FM/MW/SW)
(GRX70: E3, SP, TW/GRX70J)
CD SW board
MAIN board
PANEL board
MOTOR (TURN) board

SENSOR board
BD board
CONNECTOR board
MOTOR (SLIDE) board
LEAF SW board
AUDIO board
27
28
7-6.
PRINTED WIRING BOARD BD Board
See page 28 for Circuit Boards Location.
TP(GND)
TP(VC)
TP(RF)
TP
(AGCCON)
TP(FE)
TP(TE)
(Page 43)
TP(FE1)
19
21 , 31
21 , 31
21 , 31
21 , 31
05
05
Semiconductor
Location
(Side A)
Ref. No.
Q101
Semiconductor
Location
(Side B)
KSS-213D/Q-NP
Location
Ref. No.
C-3
IC101
IC102
IC103
29
30
Location
C-2
B-1
B-1
7-7. SCHEMATIC DIAGRAM BD Board
See page 59 for Waveforms. See page 64 for IC Block Diagrams.
(Page 45)
Voltages and waveforms are dc with respect to ground

under no-signal conditions.
no mark : CD STOP
(
) : CD PLAY
31

Replace only with part number specified.
32
Les composants identifis par une marque ! sont

critiques pour la scurit. Ne les remplacer que
par une pice portant le numro spcifi.
7-8. PRINTED WIRING BOARDS CD MOTOR Section
See page 28 for IC Circuit Boards Location.
(Page 43)
DISC TRAY
SLIDE
DISC TRAY
TURN
1-658-577-
(DISC TRAY ADDRESS DETECT)
05
C
(Page 43)
33
34
7-9. SCHEMATIC DIAGRAM CD MOTOR Section
See page 65 for IC Block Diagrams.
DISC TRAY
ADDRESS DETECT
DISC TRAY SLIDE
CLOSE
OPEN
B
(Page 45)
(DISC TRAY SLIDE)
DISC
TRAY
TURN
DISC IN DETECT
SENSOR
DISC TRAY
SENSOR
DISC TRAY TURN

MOTOR DRIVER
C
(Page 45)
LEVEL SHIFT
Voltages are dc with respect to ground under no-signal

conditions.
no mark : CD STOP
35
36
7-10.
PRINTED WIRING BOARD AUDIO Board
05
D
(Page 43)
37
38
7-11.
SCHEMATIC DIAGRAM AUDIO Board
See page 66 for IC Block Diagram.
PB EQ AMP
(DECK A)
(PLAYBACK)
PB LEVEL (L)
(DECK A)
PB LEVEL (R)
(DECK A)
PB EQ AMP
(DECK B)
PB LEVEL (L)
(DECK B)
PB LEVEL (R)
(DECK B)
D
(Page 49)
SWITCHING
REC BIAS (R)

(DECK B)
REC BIAS (L)

(DECK B)
REC BIAS
-6.8
BIAS OSC

conditions.
no mark : TAPE PLAY
(
) : RECORD
39
40

7-12.
PRINTED WIRING BOARD LEAF SW Board

Semiconductor Location
DECK A
PLUNGER
DECK B
PLUNGER
(DECK B 120/70)
(DECK A PLAY)
(DECK B REC)
(DECK B PLAY)
(DECK B HALF)
21
05
(DECK A HALF)
(DECK A 120/70)
21
(DECK A REC)
E
(Page 43)
7-13.
SCHEMATIC DIAGRAM LEAF SW Board
CONTROL SWITCH
(CAPSTAN)
DECK B
PLUNGER
DECK A
PLUNGER
ROTATION DETECT SENSOR

(DECK A)
(DECK A 120/70)
ROTATION DETECT
SENSOR (DECK B)
(DECK A HALF)
(DECK A REC)
(Page 49)
(DECK B HALF)
(DECK B REC)
(DECK B 120/70)
(DECK A PLAY)
(DECK B PLAY)

conditions.
no mark : TAPE PLAY
(
) : RECORD
: Impossible to measure
41
42
Ref. No.
Location
Ref. No.
Location
D141
D191
D331
D333
D334
D335
D401
D403
D405
D406
D407
D411
D501
D502
D503
D504
D505
D506
D509
D607
D644
D801
D802
D803
D831
D832
D851
D852
D881
D901
D902
D903
D904
D905
D906
D907
D908
D909
D910
D915
D921
D922
D923
D924
D925
E-10
E-12
E-1
F-1
E-1
F-1
G-11
F-12
H-6
J-4
I-2
G-3
D-7
E-6
D-6
D-7
D-7
D-7
F-2
E-5
C-8
J-11
G-9
G-11
I-6
J-7
J-10
G-9
H-9
J-4
J-4
J-4
I-4
I-1
H-1
J-5
I-5
J-5
J-5
I-4
H-4
G-4
G-4
F-2
G-4
IC101
IC301
IC381
IC501
IC502
IC801
IC901
IC902
IC903
C-10
B-3
A-12
D-5
D-7
H-10
G-6
G-4
H-4
Q111
Q112
D-10
D-10
Q113
Q161
Q162
Q163
Q191
Q192
Q201
Q251
Q331
Q332
Q333
Q334
Q335
Q336
Q337
Q338
Q339
Q340
Q341
Q342
Q343
Q401
Q402
Q411
Q412
Q431
Q432
Q433
Q434
Q435
Q436
Q437
Q439
Q471
Q501
Q508
Q509
Q801
Q803
Q804
Q831
Q832
Q851
Q881
Q901
Q902
Q903
Q904
Q905
Q907
Q908
Q909
Q913
Q914
Q923
Q951
Q952
E-9
C-9
C-9
E-9
E-12
E-10
D-9
C-9
C-1
C-2
C-2
C-2
D-1
F-1
F-1
F-1
F-1
E-1
E-1
F-1
E-1
F-12
E-12
G-2
G-3
G-12
G-11
F-11
F-11
F-11
F-11
G-12
F-12
F-2
D-7
D-7
E-7
H-10
G-10
G-9
G-10
G-10
J-10
I-9
H-2
I-1
H-1
G-4
G-4
G-5
G-4
I-4
H-1
G-2
H-1
G-2
H-1
7-14.
PRINTED WIRING BOARD MAIN Board
(Page 33)
(Page 33)
(Page 30)
(Page 38)
(Page 41)
(Page 53)
(Page 61)
(Page 61)
43
44
7-15.
SCHEMATIC DIAGRAM MAIN Board (1/4)
(Page 47)
(Page 31)
(Page 36)
(Page 51)
(Page 36)
(Page 50)
under no-signal (detuned) conditions.
no mark : TUNER (FM/AM)
(
) : CD PLAY
45
46
7-16.
(Page
46)
(Page 63)
(Page 50)
(Page 52)
(detuned) conditions.
no mark : FM
47

48

7-17.
(Page 46)
(Page 47)
(Page 51)
(Page 63)
(Page 56)
(Page 51)
(Page 40)
(Page 42)

(
) : CD PLAY
{
} : TAPE PLAYBACK (DECK A)
[
] : TAPE PLAYBACK (DECK B)
: RECORD
49
50
7-18.
See page 59 for Waveforms.
(Page 48)
(Page
46)
(Page
50)
(Page
50)
uPC7812AHF

(
) : CD PLAY
{
} : TAPE PLAYBACK (DECK A)
[
] : TAPE PLAYBACK (DECK B)
: RECOARD
51
52
7-19.
PRINTED WIRING BOARD PANEL Board
(Page 43)
(Page 57)
Semiconductor Location
Ref. No.
D610
D611
D612
D613
D614
D615
D616
D619
D620
D621
D622
D624
D627
Location
C-2
E-1
C-2
C-5
C-6
C-7
C-8
B-2
A-2
B-9
A-9
D-4
E-7
53
Ref. No.
Location
D628
D629
D630
D631
D632
D701
E-4
D-5
F-7
F-4
F-8
C-9
IC601
IC602
IC603
IC604
IC711
IC712
B-5
B-10
B-7
C-3
C-9
F-8
Ref. No.
Q601
Q602
Q603
Q604
Q605
Q606
Q607
Q608
Q609
Q610
Q611
Q612
Q613
Location
C-2
C-1
C-1
A-3
A-2
B-3
A-9
A-9
A-9
B-9
B-8
B-8
B-8
54
7-20.
SCHEMATIC DIAGRAM PANEL Board
See page 59 for Waveform. See page 66 for IC Block Diagrams.
(Page
58)
(Page 50)

55
56
7-21.
PRINTED WIRING BOARD CD SW Board

7-22.
SCHEMATIC DIAGRAM CD SW Board
(Page 55)
(Page 54)
57
58
Waveforms
BD Board
MAIN Board
5 IC101 @ (MDP)
1 IC101 ^ (XTAO)
1 IC501 0 (XC-IN)
2.5 Vp-p
3.1 Vp-p
16.9344 MHz
32.768 kHz
7.8 s
2 IC101 % (RF AC) (CD Play Mode)
1.8 Vp-p
6 IC102 ! (RFO) (CD Play Mode)
2 IC501 ! (XIN)
1.3 Vp-p
1.2 Vp-p
2.2 Vp-p
16 MHz
3 IC101 $ (TE) (CD Play Mode)
PANEL Board
1 IC601 & (XOUT)
0.2 Vp-p
4.7 Vp-p
12.5 MHz
4 IC101 # (FE) (CD Play Mode)
0.5 Vp-p
59
7-23.
PRINTED WIRING BOARDS TRANSFORMER Section
Semiconductor
Location
Ref. No.
Location
D971
D972
D973
A-2
A-1
A-1
Q971
A-1
(Page 43)
(Page 43)
Semiconductor
Location
Ref. No.
Location
D11
D12
D13
D14
D15
D16
D17
D18
D19
D20
D21
D22
D23
B-5
A-3
A-3
A-3
A-3
B-2
A-2
A-2
A-2
A-2
A-2
A-2
A-1
IC11
B-2
Q11
Q12
Q13
Q14
Q15
Q16
Q17
B-2
A-2
A-2
A-1
A-1
A-1
A-1
(Page 43)
61
62
7-24.
SCHEMATIC DIAGRAM TRANSFORMER Section
(Page 48)
(Page 50)
(Page
50)


63
IC Block Diagrams
BD Board
PCO
FILI
FILO
CLTV
AVSS3
RFAC
BIAS
ASYI
ASYO
AVDD0
IGEN
AVSS0
ADIO
RFDC
CE
TE
60
59 58 57
56 55 54 53
52
51 50 49 48
47
46 45
44
43 42 41
DIGITAL
OUT
LRCK 61
PCMD 62
D/A
INTERFACE
INTERNAL BUS
VDD
VSS
AVDD3
CXD2587Q
DOUT
IC101
ERROR
CORRECTOR
DIGITAL
PLL
16K
RAM
40 SE
39 FE
38 VC
ASYMMETRY
CORRECTION
OPERATIONAL
AMPLIFIER
ANALOG SWITCH
EFM
DEMODULATOR
A/D
CONVERTER
BCK 63
EMPH 64
XVDD 65
66
67
68
69
70
71
TIMING
LOGIC
CLOCK
GENERATOR
SERVO DSP
LOUT1 72
PWM
AVSS1 73
AVSS2 74
LOUT2 75
PWM
3rd ORDER
NOISE SHAPER
OVER SAMPLING
DIGITAL FILTER
AIN2 76
AOUT2 77
AVDD2 78
RMUT 79
LMUT 80
SUBCODE
PROCESSOR
PWM GENERATOR
FOCUS
SERVO
FOCUS PWM
GENERATOR
TRACKING
SERVO
TRACKING
PWM GENERATOR
SLED
SERVO
SLED PWM
GENERATOR
37 XTSL
36 TES1
35 TEST
34 VSS
33
32
31
30
29
28
FRDR
FFDR
TRDR
TFDR
SRDR
SFDR
27 SSTP
SERVO
INTERFACE
SERVO AUTO
SEQUENCER
SERIAL IN
INTERFACE
CPU
INTERFACE
DIGITAL
CLV
26 MDP
25 LOCK
MIRR, DFCT,
FOK
DETECTOR
24 FOK
23 DFCT
22 MIRR
5 6 7 8
9 10 11 12 13 14 15 16 17 18 19 20
XRST
SYSM
DATA
XLAT
CLOK
SENS
SCLK
VDD
ATSK
64
C2PO
SCOR
WFCK
XUGF
XPCK
GFS
1 2
SQSO
SQCK
21 COUT
SPOA
SPOB
XLON
XTAI
XTAO
XVSS
AVDD1
AOUT1
AIN1
IC103
CXA2568M-T6
VCC
HOLD 1
VCC
APC PD AMP
+
24 VCC
23 LC/PD
APC LD AMP
VEE
22 LD ON
21 HOLD SW
20 AGC CONT
VEE
AGC VTH 2
50A
LD 3
VCC
PD 4
19 RF BOT
VC
+
VC
A 5
B 6
VEE
18 RFTC
RF SUMMING AMP
C 7
VC
RF EQ AMP
VC
17 RF I
16 RF O
D 8
15 RFE
VC
FOCUS ERROR AMP
VEE
VEE 9
14 FE
VC
VC
+
F 10
E 11
VC
VC
VC BUFFER
VC 12
13 TE
TRACKING
ERROR AMP
VC
VEE
VCC
VC
MOTOR (TURN) Board
MOTOR (SLIDE) Board
IC701
IC801
M54641L
VCC 1
OUT2 2
RIN 2
8 VCC
VREF 3
OUT2 4
INPUT
AMP.
RNF 5
CONTROL
POWER AMP.
INPUT
AMP.
GND 6
7 OUT1
OUT1 7
VM 8
POWER AMP.
GND 4
POWER
SAVE
GND 1
REG
IN1 3
BA6286N
6 IN2
5 REFERENCE
VCC 9
FIN 10
65
TSD
CONTROL
LOGIC
AUDIO Board
IC602
PC1330HA
INVERTER
COMPARATER
2
SW P1 CONT
SW R1 GND
GND
VCC
SW P2 GND
9
SW R2
PANEL Board
BA3830F
IC604
NJU3716M-T2
VDD
P6
P5
P4
P3
P2
VSS
P1
CLR
STB
CLK
DATA
IC603
R02
REFERENCE
CURRENT
R01
REFERENCE
CURRENT
LINE NF
LINE IN
RESET
17
16
15
14
13
12
BAND
PASS
FILTER
DET
RESET C
BIAS C
GND
7
8
9
CONTROL
CIRCUIT
F01
F02
F03
F04
F05
F06
SHIFT REGISTER
LATCH CIRCUIT
11 REC LEVEL
OUTPUT CIRCUIT
10 VCC
VCC
CLOCK
REF
OP2IN
OP2OUT
LPF2IN
LPF2OUT
IC711 M65850FP (HCD-GRX70J: Saudi Arabia)
14
13
12
11
10
OSCILLATOR
D/A
LPF2
1/2 VCC
DO1
CLOCK
AUTO
RESET
RESET
MAIN
CONTROL
D1
DO0
MO
20KBIT
SRAM
MI
A/D
LPF1IN
LPF1OUT
OP1OUT
OP1IN
CC1
CC2
GND
LPF1
66
1 2 3 4 5 6 7 8 9 10 11
12
SO
REC IN
24 23 22 21 20 19 18 17 16 15 14 13
P7
P8
P9
P10
P11
VSS
P12
P13
P14
P15
P16
REC NF
18 RESET
7-25.
IC PIN FUNCTION DESCRIPTION
MAIN BOARD IC501 M30622MA-A07FP (SYSTEM CONTROLLER (CD MECHANISM CONTROL))

Pin No.
Pin Name
I/O
Description
STK-MUTE
Power amplifier on/off selection signal output terminal L: standby mode, H: on
POWER
Power on/off control signal output for the audio system (+5V) and deck, panel, audio system
(+7V) L: standby mode, H: power on
F-RELAY
Relay drive signal output for the speaker protect H: relay on
R-RELAY
Relay drive signal output for the speaker protect H: relay on Not used (open)
CD-POWER
Power on/off control signal output for the CD mechanism deck section
L: standby mode, H: power on
LINE-MUTE
Line muting on/off control signal output terminal L: muting on
DBFB-H/L
DBFB normal/high selection signal output to the M62493FP (IC101)

L: DBFB high, H: DBFB low
BYTE
External data bus line byte selection signal input terminal Fixed at L in this set
CNVSS
10
XC-IN
Sub system clock input terminal (32.768 kHz)
11
XC-OUT
Sub system clock output terminal (32.768 kHz)
12
RESET
System reset signal input from the reset signal generator (IC502) L: reset
For several hundreds msec. after the power supply rises, L is input, then it changes to H
13
X-OUT
Main system clock output terminal (16 MHz)
14
VSS
Ground terminal
15
X-IN
16
VCC
17
NMI
Non-maskable interrupt input terminal Fixed at H in this set
18
WAKE UP
Wakeup control signal input from the fluorescent indicator tube driver (IC601) H active
Ground terminal
Main system clock input terminal (16 MHz)

Power supply terminal (+5V)
19
SCOR
Subcode sync (S0+S1) detection signal input from the CXD2587Q (IC101) on the CD block
20
RDS-INT
Serial data transfer clock signal input terminal Not used (fixed at L)
21
RDS-DATA
Serial data input terminal Not used (fixed at L)
22
AC-CUT
AC off detection signal input from the reset signal generator (IC502) L: AC cut checked
23
PL-CLK
Serial data transfer clock signal output to the pro-logic circuit Not used (open)
24
PL-DATA
Serial data output to the pro-logic circuit Not used (open)
25
PL-LAT
Serial data latch pulse output to the pro-logic circuit Not used (open)
26
TIMER LED
LED drive signal output of the TIMER SELECT indicator (D632) H: LED on
27
PROTECTOR
Protect on/off detection signal input from the speaker protect circuit
L: protect on, H: protect off
28
V MUTE
Muting on/off control signal output terminal L: muting off Not used (open)
29
IIC-CLK
I/O
Communication data reading clock signal input or transfer clock signal output with the fluorescent indicator tube driver (IC601)
30
IIC-DATA
I/O
Communication data bus with the fluorescent indicator tube driver (IC601)
31
NCO
Not used (open)
32
SQ-DATA
Subcode Q data input from the CXD2587Q (IC101) on the CD block
33
SQ-CLK
Subcode Q data reading clock signal output to the CXD2587Q (IC101) on the CD block
34
SW MODE
Not used (open)
35
CD-DATA
Serial data output to the CXD2587Q (IC101) on the CD block
36
RY-SW
Connection detect signal input of the headphone jack (J701)

L: no connected, H: headphone connected
37
CD-CLK
Serial data transfer clock signal output to the CXD2587Q (IC101) on the CD block
38
493-LATCH
Serial data latch pulse output to the M62493FP (IC101)
39
STBY LED
LED drive signal output of the I/u indicator (D754) H: LED on (standby mode)
67
Pin No.
Pin Name
I/O
Description
40
VC L+R/LR
Virtual cinema L+R/LR selection signal output terminal Not used (open)
41
VC BYPASS
Virtual cinema bypass control signal output terminal Not used (open)
42
FL SW
Filament on/off selection signal output for the fluorescent indicator tube (FL601)
L: on, H: off Used for the HCD-RXD80 model only
43
STBY RELAY
Main power on/off control signal output terminal L: standby mode, H: power on
Used for the HCD-RXD80 model only
44
BASS FREQ.
Sync bass frequency normal/high selection signal output to the M62493FP (IC101)
L: sync bass off (normal), H: sync bass high
45
FUNC SEL1
Not used (open)
46
FUNC SEL0
Not used (open)
47
493-DATA
Serial data output to the M62493FP (IC101)
48
493-CLK
Serial data transfer clock signal output to the M62493FP (IC101)
49
ST-MUTE
Tuner muting control signal output to the FM/AM tuner unit H: muting on
50
STEREO
FM stereo detection signal input from the FM/AM tuner unit L: stereo
51
TUNED
Tuning detection signal input from the FM/AM tuner unit L: tuned
52
ST-CE
PLL chip enable signal output to the FM/AM tuner unit
53
ST-DOUT
PLL serial data output to the FM/AM tuner unit
54
ST-DIN
PLL serial data input from the FM/AM tuner unit
55
ST-CLK
PLL serial data transfer clock signal output to the FM/AM tuner unit
56
SENSE
Internal status detection monitor input from the CXD2587Q (IC101) on the CD block
57
HOLD
Laser power control signal output to the CXA2568M (IC103) on the CD block
58
XLT
Serial data latch pulse output to the CXD2587Q (IC101) on the CD block
59
XRST
Reset signal output to the CXD2587Q (IC101) and BA5974FP (IC102) on the CD block
L: reset
60
DISC-SENS
Disc status detection signal input from the disc sensor (IC703)
61
TBL-SENS
Disc tray status detection signal input from the disc tray sensor (IC702)
62
VCC
63
TBL-L
Motor drive signal output to the disc tray turn motor driver (IC701) L active *1
64
VSS
Ground terminal
65
TBL-R
Motor drive signal output to the disc tray turn motor driver (IC701) L active *1
66
LOAD-OUT
Motor drive signal output to the disc tray slide motor driver (IC801) H active *2
67
LOAD-IN
Motor drive signal output to the disc tray slide motor driver (IC801) H active *2
68 to 70
ENC3 to ENC1
Detection signal input from the disc tray address detect rotary encoder (S811)
71
OUT-OPEN
Detection signal input from the disc tray open/close detect switch (S801)
L: open, H: close
72
B-TRG
Deck-B side trigger plunger drive signal output terminal H: plunger on
73
A-TRG
Deck-A side trigger plunger drive signal output terminal H: plunger on
74
CAPM-CNT2
Capstan motor (M1) drive signal output terminal H active *3
75
CAPM-CNT1
Capstan motor (M1) drive signal output terminal H active *3
76
CAP-M-H/L
High/normal speed selection signal output of the capstan motor (M1)

L: normal speed, H: high speed
*1 Disc tray turn motor (M701) control

Mode
*2 Disc tray slide motor (M801) control
Stop
Counterclockwise
Clockwise
Brake
TBL-L (pin ^)
TBL-R (pin ^)
Terminal
Mode
Stop
Table In
Table Out
Brake
LOAD-OUT (pin ^)
LOAD-IN (pin ^)
Terminal
68
Pin No.
Pin Name
I/O
Description
77
AMS-IN
Whether a music is present or not from HA12215F (IC301) is detected at automatic music sensor
L: music is present, H: music is not present
78
TC-MUTE
Line muting on/off selection signal output to the HA12215F (IC301)

L: muting off, H: muting on
79
R/P-PASS
Recording/playback/pass selection signal output to the HA12215F (IC301)

L: recording mode, H: pass, Hi-z: playback mode
80
NR-ON/OFF
Dolby NR on/off selection signal output to the HA12215F (IC301)

L: dolby off, H: dolby on
81
REC-MUTE
Recording muting on/off selection signal output to the HA12215F (IC301)

L: muting on, H: muting off
82
BIAS
Recording bias on/off selection signal output to the HA12215F (IC301)

L: bias off, H: bias on
83
EQ-H/N
Normal/high speed selection signal output to the HA12215F (IC301)

L: normal speed, H: high speed
84
PB-A/B
Deck-A/B selection signal output to the HA12215F (IC301)
85
ALC-ON/OFF
Automatic limiter control signal output to the HA12215F (IC301)
86
B-PLAY-SW
Detection input from the deck- B play detect switch (S1002)
H: deck-B play
87
A-PLAY-SW
Detection input from the deck- A play detect switch (S1001)
H: deck-A play
L: deck-A, H: deck-B
L: limiter on
88
A-HALF
Detection input from the deck-A cassette detect switch (S1003)

L: cassette in, H: no cassette
89
B-HALF
Detection input from the deck-B half detect switch (S1006)
90
B-SHUT
Shut off detection signal input from the deck-B side reel pulse detector (IC1002)
91
A-SHUT
Shut off detection signal input from the deck-A side reel pulse detector (IC1001)
92
SOFT-TEST
Output terminal for the software test (open)
93
HEADPHONE
MUTE
Muting on/off control signal output terminal
94
KEY/CD ADJ
Setting terminal for the CD adjustment mode
95
MODEL-IN
Destination setting terminal
96
AVSS
97
SPEC-IN
Setting terminal for the version
98
AVREF
Reference voltage (+5V) input terminal (for A/D conversion)
99
AVCC
Power supply terminal (+5V) (for A/D conversion)
100
TC-RELAY
Recording/playback select signal output to the REC/PB switch (IC602)

L: playback, H: recording
Stop
Forward
Direction
Reverse
Direction
Brake
CAPM-CNT1 (pin &)
CAPM-CNT2 (pin &)
Terminal
Not used (open)
Not used (open)
Ground terminal (for A/D conversion)
*3 Capstan motor (M1) control

Mode
L: muting on
69
PANEL BOARD IC601 TMP88CS76F-6004 (FLUORESCENT INDICATOR TUBE DRIVER, KEY CONTROL)
Pin No.
Pin Name
I/O
Description
SIRCS
Remote control signal input from the remote control receiver (IC602)
JOG-A
Jog dial pulse input from the rotary encoder (S601 JOG) (A phase input)
LED SCK
Serial data transfer clock signal output to the LED driver (IC604)
LED LAT
Serial data latch pulse signal output to the LED driver (IC604)
LED DATA
Serial data output to the LED driver (IC604)
PAD LAT
Not used (open)
L SEL
LED selection signal output terminal
JOG-B
Jog dial pulse input from the rotary encoder (S601 JOG) (B phase input)
VOL-A
Jog dial pulse input from the rotary encoder (S602 VOLUME) (A phase input)
10
VOL-B
Jog dial pulse input from the rotary encoder (S602 VOLUME) (B phase input)
11
KEY0
Key input terminal (A/D input) (S625 to S630)

REC PAUSE/START, HI-DUB, CD SYNC, LOOP, DISPLAY, SPECTRUM ANALYZER keys
input
12
KEY1

SYNC BASS, SYNC EQ, KARAOKE PON/MPX, NON-STOP, SURROUND, DBFB,
ENTER/NEXT, + ), 0, GROOVE, FLASH, REPEAT STEREO/MONO, PLAY MODE
DOLBY NR, EDIT DIRECTION TUNER MEMORY keys input
13
KEY2
Key input terminal (A/D input) (S638 to S642 and S751 to S757)
TIMER SELECT, P FILE MEMORY, GEQ CONTROL, FILE SELECT, EFFECT, I/u,
(STANDBY) POWER SAVE DEMO, DISC 1/2/3, DISC SKIP EX-CHANGE, keys input
14
KEY3

TUNER/BAND, ( P CD, p, ( TAPE B, 9 TAPE B, ( TAPE A, 9 TAPE A,
FUNCTION, CLOCK/TIMER SET keys input
15
GRAD L2
Not used (open)
16
S LOW FREQ
(BPF0)
Spectrum analyzer drive (super low frequency) signal input from the spectrum analyzer bandpass filter (IC603) (for 40 Hz)
17
BPF1
Spectrum analyzer drive (low frequency) signal input from the spectrum analyzer band-pass filter
(IC603) (for 100 Hz)
18
BPF2
Spectrum analyzer drive (low and middle frequency) signal input from the spectrum analyzer
band-pass filter (IC603) (for 400 Hz)
19
BPF3
Spectrum analyzer drive (middle and high frequency) signal input from the spectrum analyzer
band-pass filter (IC603) (for 2 kHz)
20
BPF4
Spectrum analyzer drive (high frequency) signal input from the spectrum analyzer band-pass filter
(IC603) (for 6 kHz)
21
ALL BAND
(L+R)
Spectrum analyzer drive signal input from the spectrum analyzer band-pass filter (IC603)
(for VACS, non-stop signal)
22
WAKE UP
Wakeup control signal output to the system controller (IC501)
23
VSS
Ground terminal
24
VASS
Ground terminal (for A/D conversion)
25
VAREF
26
VDD
27 to 32
G18 to G13
Grid drive signal output to the fluorescent indicator tube (FL601)
33 to 40
G12 to G5
41
VDD
42 to 44
G4 to G2
45
G1
46 to 67
S1 to S22
Segment drive signal output to the fluorescent indicator tube (FL601)
68
VKK
Power supply terminal (30V) (for fluorescent indicator tube drive)
H active
Reference voltage (+5V) input terminal (for A/D conversion)
70
Pin No.
Pin Name
I/O
69
VDD
Description
70
XIN
71
VSS
Ground terminal
72
XOUT
System clock output terminal (12.5 MHz)
73
RESET
System reset signal input from the reset signal generator (IC502) L: reset
For several hundreds msec. after the power supply rises, L is input, then it changes to H
74
CH
Not used (open)
75
BUSY
Not used (fixed at L)
76
TEST
Connected to ground
77
GRAD R1
Not used (open)
78
I2C DATA
I/O
Communication data bus with the system controller (IC501)
79
I2C CLK
I/O
Communication data reading clock signal input or transfer clock signal output with the system
controller (IC501)
80
GRAD R2
Not used (open)
System clock input terminal (12.5 MHz)
71
SECTION 8
EXPLODED VIEWS
NOTE:
-XX and -X mean standardized parts, so they
may have some difference from the original
one.
Color Indication of Appearance Parts
Example:
KNOB, BALANCE (WHITE) . . . (RED)
Parts Color Cabinet's Color

Abbreviation
EA3
MX
SP
TH
TW
(1)
Items marked * are not stocked since they

are seldom required for routine service. Some
delay should be anticipated when ordering
these items.
The mechanical parts with no reference number in the exploded views are not supplied.
Hardware (# mark) list is given in the last of
the electrical parts list.
: Saudi Arabia model
: Mexican model
: Singapore model
: Thai model
: Taiwan model
The components identified by

mark ! or dotted line with mark
! are critical for safety.
Replace only with part number
specified.
Les composants identifis par une
marque ! sont critiquens pour la
scurit.
Ne les remplacer que par une pice
portant le numro spcifi.
#1
COVER SECTION
5
front panel section
3
#4
not supplied
#3
#4
10
not supplied
#3
7
TCM-230AWR2
8
#5
not supplied
Ref. No.
#3
#5
10
Part No.
Description
Remark
1
1
2
2
3
X-4950-832-1
X-4950-971-1
X-4950-828-1
X-4950-970-1
X-4950-756-1
HOLDER (R) ASSY, CASSETTE (SILVER)

HOLDER (R) ASSY, CASSETTE (GRAY)
HOLDER (L) ASSY, CASSETTE (SILVER)
HOLDER (L) ASSY, CASSETTE (GRAY)
PANEL ASSY, LOADING (SILVER)
3
3
3
4
X-4951-575-1
X-4951-580-1
X-4951-581-1
3-363-099-01
PANEL ASSY, LOADING (GRX70J)

PANEL ASSY, LOADING (RXD80)
PANEL ASSY, LOADING (GRX70: E3)
SCREW (CASE 3 TP2) (3X8) (GRAY)
#6
Ref. No.
Part No.
Description
4
5
5
* 6
* 6
3-363-099-11
3-363-099-41
3-363-099-71
4-214-443-01
4-215-752-61
SCREW (CASE 3 TP2) (3X8) (SILVER)

SCREW (CASE 3 TP2) (3X12) (GRAY)
SCREW (CASE 3 TP2) (3X12) (SILVER)
COVER (SILVER)
COVER (GRAY)
4-951-620-01
4-215-062-01
4-985-642-01
4-219-087-01
SCREW (2.6X8), +BVTP

DAMPER
CUSHION
SPRING, TENSION
7
8
9
10
72
Remark
(2)
FRONT PANEL SECTION
60
63
64
60
62
59
60
EA3
61
61
53
60
supplied with
S601
60
58
59
54
57
supplied with
S602
52
56
55
Ref. No.
51
Part No.
54
Description
51
Remark
51
51
51
52
X-4950-869-1 PANEL ASSY, FRONT

(GRX70: E2, SP, TH, TW, MX, AR, AUS)
X-4951-598-1 PANEL ASSY, FRONT (GRX70: E3/GRX70J: E3)
X-4951-599-1 PANEL ASSY, FRONT (GRX70J: EA3)
X-4951-600-1 PANEL ASSY, FRONT (RXD80)
4-930-336-61 FOOT (FELT)
53
54
55
56
57
4-962-708-71
4-214-775-11
4-214-761-11
4-214-760-11
4-214-384-11
57
4-214-384-51 KNOB (VOL) (GRAY)
EMBLEM (4-A), SONY

SPRING, PUSH CATCHER RETURN
CATCHER (B), PUSH
CATCHER (A), PUSH
KNOB (VOL) (SILVER)
Ref. No.
Part No.
Description
58
58
* 59
60
61
4-214-383-11
4-214-383-51
4-996-716-01
4-951-620-01
4-214-385-11
KNOB (JOG) (SILVER)

KNOB (JOG) (GRAY)
HOLDER (CDM)
KNOB (MIC) (SILVER)
61
* 62
62
62
* 63
4-214-385-51
A-4417-808-A
A-4419-985-A
A-4426-002-A
A-4417-727-A
KNOB (MIC) (GRAY)

PANEL BOARD, COMPLETE (GRX70/RXD80)
PANEL BOARD, COMPLETE (GRX70J: E3)
PANEL BOARD, COMPLETE (GRX70J: EA3)
CD SW BOARD, COMPLETE
64
73
1-773-188-11 WIRE (FLAT TYPE) (23 CORE)
Remark
(3)
CHASSIS SECTION
CDM38LH-5BD32L
RXD80
T11
not supplied
#2
113
106
108
107
#9
RXD80
#2
#2
#10
#10
105
102
#2
GRX70/
GRX70J
#3
#2
#2
104
#2
109
#2
103
#2
M501
T951
110
111
112
E3
111
E2, E3, TH, MX
CND
not supplied
112
101
111
EA3, SP,
TW
EA3, SP, TW, AR
74
111
AUS
Ref. No.
Part No.
Remark
Ref. No.
101
* 102
* 103
4-965-822-01 FOOT
1-672-369-11 TRANS BOARD
3-703-244-00 BUSHING (2104), CORD (GRX70: SP, TW,
AUS/GRX70J: EA3/RXD80)
3-703-571-11 BUSHING (S) (4516), CORD
(GRX70: E2, E3, TH, MX, AR/GRX70J: E3)
1-773-042-11 WIRE (FLAT TYPE) (17 CORE) (14cm)
(GRX70: E3, TW, AR, AUS/RXD80)
* 108
* 108
109
103
104
104
105
106
* 107
* 107
107
107
107
* 107
* 108
Description

(GRX70: E2, SP, TH, MX/GRX70J)
A-4417-812-A MAIN BOARD, COMPLETE
(GRX70: E2, MX, AR)
(GRX70: E3, SP, TW)
A-4419-816-A MAIN BOARD, COMPLETE (RXD80)
(GRX70: TH, AUS)
A-4419-991-A MAIN BOARD, COMPLETE (GRX70J: E3)
A-4426-000-A MAIN BOARD, COMPLETE (GRX70J: EA3)
4-214-456-61 PANEL, BACK (GRX70: TH)
109
110
110
110
110
110
! 111
! 111
! 111
! 111
! 111
! 112
! 112
*
*
*
*
*
108
108
108
108
108
* 108
* 108
4-215-169-01
4-215-169-11
4-215-169-21
4-215-169-31
4-216-169-51
PANEL, BACK (GRX70: E2, AR)

PANEL, BACK (GRX70: SP)
PANEL, BACK (GRX70: MX)
PANEL, BACK (GRX70J: EA3)
PANEL, BACK (GRX70J: E3)
4-219-987-01 PANEL, BACK (RXD80)

4-219-987-21 PANEL, BACK (GRX70: E3)
Part No.
Description
Remark
4-219-987-31 PANEL, BACK (GRX70: TW)

4-219-987-41 PANEL, BACK (GRX70: AUS)
(GRX70: E2, TH, MX, AR, AUS/ RXD80)
1-233-544-14 TUNER PACK (RXD80)
1-233-545-11 TUNER (FM/AM) (GRX70: TH, AUS)
1-233-545-14 TUNER PACK (GRX70: MX, AR)
1-233-546-11 TUNER (FM/MW/SW)
1-693-453-11 TUNER (FM/AM) (GRX70: E2)
1-575-651-11 CORD, POWER
(GRX70: SP, TW/GRX70J: EA3)
1-575-653-11 CORD, POWER
(GRX70: E2, E3, TH, MX/GRX70J: E3)
1-690-608-11 CORD, POWER (GRX70: AUS)
1-690-609-21 CORD, POWER (RXD80: CND)
1-783-941-21 CORD, POWER (GRX70: AR)
1-569-007-11 ADAPTOR, CONVERSION 2P
(GRX70: E3/GRX70J: E3)
* 113
M501
! T11
! T951

A-4417-729-A SUB TRANS BOARD, COMPLETE (RXD80)
1-698-792-11 FAN, DC
1-433-587-11 TRANSFORMER, POWER (RXD80)
1-433-561-11 TRANSFORMER, POWER (GRX70/GRX70J)
! T951

mark ! or dotted line with
mark ! are critical for safety.
75

marque ! sont critiques pour la
scurit.
(4)
CD MECHANISM DECK SECITON-1

(CDM38LH-5BD32L)
201
202
201
206
203
M701
204
211
#2
#8
205
207
208
210
212
209
#2
Ref. No.
201
202
203
204
205
* 206
207
Part No.
Description
4-981-789-11
4-977-945-01
X-4946-665-1
4-977-943-01
4-977-956-01
BRACKET (2), YOKE

TRAY (TURN)
SHAFT ASSY, WORM
BELT (TURN) (1.2)
WHEEL, WORM
Remark
Ref. No.
208
* 209
210
211
212
M701
1-658-577-11 MOTOR (TURN) BOARD

4-988-162-01 ROLLER
76
Part No.
4-977-941-01
1-658-576-11
4-934-376-01
4-981-187-01
4-977-944-01
Description
BEARING (WORM)
SENSOR BOARD
SHAFT (ROLLER)
COLLAR (WORM)
TRAY (SLIDE)
A-4672-004-A MOTOR ASSY (DISC TRAY TURN)
Remark
(5)
CD MECHANISM DECK SECITON-2

(CDM38LH-5BD32L)
251
253
251
252
255
254
257
258
not
supplied
256
259
270
266
#2
260
267
269
268
261
261
M801
BU-5BD32L
262
S811
263
#2
263
264
265
251
Ref. No.
Part No.
Description
251
252
253
254
255
4-981-789-11
4-977-954-01
4-977-953-01
4-977-955-01
4-977-942-01
BRACKET (2), YOKE

PULLEY (SL)
GEAR (SL-A)
GEAR (SL-B)
BELT (SL) (1.4)
256
257
258
* 259
* 260
X-4946-667-1
1-452-925-21
1-776-042-11
1-658-575-11
X-4946-668-1
CAM ASSY, BU
MAGNET ASSY
WIRE (FLAT TYPE) (8 CORE)
CONNECTOR BOARD
CHASSIS (CDM) ASSY
261
4-985-672-01 SCREW (+PTPWHM2.6), FLOATING
Remark
Ref. No.
Part No.
Description
* 262
263
264
265
266
1-658-578-11
4-982-447-01
4-951-620-41
X-4949-570-1
4-989-494-01
MOTOR (SLIDE) BOARD

SPRING (BU), COMPRESSION
SCREW (2.6), +BVTP
HOLDER (BU) ASSY
SCREW (SLIDER), STEP
267
268
269
270
M801
4-989-492-11
4-989-819-02
4-989-491-11
4-993-142-21
A-4672-004-A
SLIDER (38)
SPRING, TENSION
COVER (2), LENS
PULLEY (L), PRESS
MOTOR ASSY (DISC TRAY SLIDE)
S811
1-473-335-11 ENCODER, ROTARY (BU, TRAY ADDRESS DET)
77
Remark
(6)
BASE UNIT SECTION

(BU-5BD32L)
301
302
309
303
305
M101
304
M102
304
306
307
308
Ref. No.
Part No.
Description
! 301
302
303
304
305
8-820-020-02
1-769-069-11
4-917-567-01
4-951-940-01
4-917-565-01
OPTICAL PICK-UP KSS-213D/Q-NP

GEAR (M)
INSULATOR (BU)
SHAFT, SLED
306
Remark

scurit.
Ref. No.
Part No.
Description
* 307
308
309
M101
M102
A-4724-486-A
4-951-620-01
3-713-786-51
X-4917-523-4
X-4917-504-1
BD BOARD, COMPLETE
SCREW +P 2X3
MOTOR ASSY (SPINDLE)
MOTOR ASSY (SLED)
4-917-564-01 GEAR (P), FLATNESS
78
Remark
(7)
TAPE MECHANISM DECK SECTION-1

(TCM-230AWR2)
408
408
411
407
410
406
404
HP101
403
407
HRPE101
403 405
406
404
405
412
413
409
402
402
401
Ref. No.
Part No.
Description
401
402
403
404
405
3-376-464-11
3-036-914-01
3-016-574-11
X-3374-156-4
X-3374-155-4
SCREW (+PTT 2.6X6), GROUND POINT

RIVET
SPRING (HEAD), TENSION
PINCH LEVER (REV) ASSY
PINCH LEVER (FWD) ASSY
Remark
406
407
408
3-016-564-01 BASE (PINCH LEVER FWD)

3-016-565-01 BASE (PINCH LEVER REV)
3-026-892-01 SPRING (CASSETTE), LEAF
Ref. No.
Part No.
Description
* 409
410
411
412
413
A-2007-731-A
3-032-809-02
3-016-572-01
3-032-810-02
3-016-573-01
AUDIO BOARD, COMPLETE

SPRING (L), TORSION
LEVER (EJECT PREVENTION L)
SPRING (R), TORSION
LEVER (EJECT PREVENTION R)
HP101 A-2056-681-A DECK (A) ASSY, HEAD

HRPE101A-2056-682-A DECK (B) ASSY, HEAD
79
Remark
(8)
TAPE MECHANISM DECK SECTION-2

(TCM-230AWR2)
461
451
#7
462
459
463
460
455
458
#10
#12
#10
#10
#11
460
452
454
456
#10
459
458
464
455
452
M1
456
457
453
Ref. No.
Part No.
Description
* 451
452
453
454
455
X-3374-214-3
3-016-570-01
3-016-569-01
3-017-360-01
X-3376-497-1
456
457
458
Remark
Ref. No.
Part No.
Description
CHASSIS ASSY, MAIN

BELT (CAPSTAN)
BELT (TENSION)
BRACKET (MOTOR)
FLYWHEEL (FWD) ASSY
459
460
* 461
462
463
A-2004-629-A
3-016-566-01
A-2007-732-A
3-016-575-11
3-019-208-01
MECHANICAL BLOCK ASSY

SLIDER, REVERSE
LEAF SW BOARD, COMPLETE
SPRING, TORSION
WASHER, STOPPER
X-3374-235-1 FLYWHEEL (REV) ASSY

X-3374-238-1 PULLEY ASSY, TENSION
3-024-405-01 BELT (FR2)
464
465
M1
80
3-027-453-01 SPRING (GROUND), TENSION

3-030-823-01 SCREW (+BVTT) (2X3.5)
A-2004-628-A MOTOR ASSY, CAPSTAN
Remark
SECTION 9
ELECTRICAL PARTS LIST
NOTE:
Due to standardization, replacements in the
parts list may be different from the parts specified in the diagrams or the components used
on the set.
-XX and -X mean standardized parts, so they
may have some difference from the original
one.
RESISTORS
All resistors are in ohms.
METAL: Metal-film resistor.
METAL OXIDE: Metal oxide-film resistor.
F: nonflammable
Abbreviation
E2
E3
EA3
MX
Items marked * are not stocked since they

are seldom required for routine service.
Some delay should be anticipated when ordering these items.
SEMICONDUCTORS
In each case, u: , for example:
uA. . : A. .
uPA. . : PA. .
uPB. . : PB. .
uPC. . : PC. .
uPD. . : PD. .
CAPACITORS
uF: F
COILS
uH: H

: Saudi Arabia model
: Mexican model
Ref. No.
Part No.
A-2007-731-A AUDIO BOARD, COMPLETE

**********************
AUDIO
Description

mark ! or dotted line with mark
! are critical for safety.
Replace only with part number
specified.
marque ! sont critiquens pour la
scurit.
When indicating parts by reference
number, please include the board.
TH : Thai model
TW : Taiwan model
Remark
Ref. No.
Part No.
Description
Remark
< CONNECTOR >

CN601
1-568-834-11 SOCKET, CONNECTOR 15P
< CAPACITOR >

< IC >
C301
C302
C303
C304
C305
1-162-289-31
1-126-968-11
1-162-282-31
1-130-483-00
1-107-715-11
CERAMIC
ELECT
CERAMIC
MYLAR
ELECT
390PF
100uF
100PF
0.01uF
22uF
10%
20%
10%
5%
20%
50V
6.3V
50V
50V
16V
C311
C313
C314
C315
C331
1-162-289-31
1-162-282-31
1-130-487-00
1-126-233-11
1-137-427-11
CERAMIC
CERAMIC
MYLAR
ELECT
FILM
390PF
100PF
0.022uF
22uF
120PF
10%
10%
5%
20%
5%
50V
50V
50V
50V
50V
C332
C333
C401
C402
C403
1-162-288-31
1-162-209-31
1-162-289-31
1-126-968-11
1-162-282-31
CERAMIC
CERAMIC
CERAMIC
ELECT
CERAMIC
330PF
27PF
390PF
100uF
100PF
10%
5%
10%
20%
10%
50V
50V
50V
6.3V
50V
C404
C405
C411
C413
C414
1-130-483-00
1-107-715-11
1-162-289-31
1-162-282-31
1-130-487-00
MYLAR
ELECT
CERAMIC
CERAMIC
MYLAR
0.01uF
22uF
390PF
100PF
0.022uF
5%
20%
10%
10%
5%
50V
16V
50V
50V
50V
C415
C431
C432
C433
C601
1-126-233-11
1-137-427-11
1-162-288-31
1-162-209-31
1-104-396-11
ELECT
FILM
CERAMIC
CERAMIC
ELECT
22uF
120PF
330PF
27PF
10uF
20%
5%
10%
5%
20%
50V
50V
50V
50V
16V
C602
C611
C612
C621
C622
1-104-396-11
1-104-396-11
1-104-396-11
1-137-150-11
1-126-961-11
ELECT
ELECT
ELECT
FILM
ELECT
10uF
10uF
10uF
0.01uF
2.2uF
20%
20%
20%
5%
20%
16V
16V
16V
100V
50V
C623
C624
C625
C627
C628
1-136-155-00
1-130-481-00
1-130-481-00
1-124-903-11
1-136-153-00
FILM
MYLAR
MYLAR
ELECT
FILM
0.015uF
0.0068uF
0.0068uF
1uF
0.01uF
5%
5%
5%
20%
5%
50V
50V
50V
50V
50V
C642
1-104-664-11 ELECT
47uF
20%
16V
IC601
IC602
IC611
8-759-111-44 IC uPC4570C-1
8-759-143-54 IC uPC1330HA
8-759-111-44 IC uPC4570C-1
< COIL >
L331
L431
L601
L602
1-410-780-11
1-410-780-11
1-414-193-41
1-414-193-41
INDUCTOR
INDUCTOR
INDUCTOR
INDUCTOR
27mH
27mH
220uH
220uH
< TRANSISTOR >

Q621
Q622
Q623
8-729-142-46 TRANSISTOR 2SC2001-LK

8-729-142-46 TRANSISTOR 2SC2001-LK
8-729-801-93 TRANSISTOR 2SD1387
< RESISTOR >
R301
R302
R303
R304
R305
1-247-881-00
1-249-409-11
1-249-433-11
1-247-889-00
1-247-858-11
CARBON
CARBON
CARBON
CARBON
CARBON
120K
220
22K
270K
13K
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
1/4W
R311
R312
R314
R315
R331
1-247-881-00
1-247-807-31
1-247-882-11
1-247-850-11
1-249-430-11
CARBON
CARBON
CARBON
CARBON
CARBON
120K
100
130K
6.2K
12K
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
1/4W
R401
R402
R403
R404
R405
1-247-881-00
1-249-409-11
1-249-433-11
1-247-889-00
1-247-858-11
CARBON
CARBON
CARBON
CARBON
CARBON
120K
220
22K
270K
13K
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
1/4W
R411
R412
R414
R415
R431
1-247-881-00
1-247-807-31
1-247-882-11
1-247-850-11
1-249-430-11
CARBON
CARBON
CARBON
CARBON
CARBON
120K
100
130K
6.2K
12K
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
1/4W
R601
1-249-409-11 CARBON
220
5%
1/4W
81
AUDIO
Ref. No.
BD
Part No.
Description
R602
R608
R609
R611
1-249-409-11
1-249-409-11
1-249-433-11
1-249-409-11
CARBON
CARBON
CARBON
CARBON
220
220
22K
220
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
R612
! R621
! R622
R623
R624
1-249-409-11
1-212-851-00
1-212-851-00
1-249-432-11
1-249-432-11
CARBON
FUSIBLE
FUSIBLE
CARBON
CARBON
220
5.6
5.6
18K
18K
5%
5%
5%
5%
5%
1/4W
1/4W F
1/4W F
1/4W
1/4W
1-249-429-11 CARBON
10K
5%
1/4W
R625
Remark
< VARIABLE RESISTOR >

RV301
RV311
RV341
RV401
RV411
1-238-598-11
1-238-598-11
1-241-768-11
1-238-598-11
1-238-598-11
RES, ADJ, CARBON 2.2K

RES, ADJ, CARBON 220K
RV441
1-241-768-11 RES, ADJ, CARBON 220K
Ref. No.
Part No.
Description
C143
C151
C153
C154
C156
1-163-038-00
1-163-235-11
1-163-038-00
1-110-501-11
1-163-235-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1uF
22PF
0.1uF
0.33uF
22PF
C157
C159
C161
C162
C163
1-163-009-11
1-163-019-00
1-126-206-11
1-126-205-11
1-126-206-11
CERAMIC CHIP
CERAMIC CHIP
ELECT CHIP
ELECT CHIP
ELECT CHIP
C165
C167
C168
C171
C172
1-163-038-00
1-163-235-11
1-163-235-11
1-163-009-11
1-163-123-00
C181
C182
10%
5%
0.001uF
0.0068uF
100uF
47uF
100uF
10%
10%
20%
20%
20%
50V
50V
6.3V
6.3V
6.3V
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1uF
22PF
22PF
0.001uF
180PF
5%
5%
10%
5%
25V
50V
50V
50V
50V
1-163-009-11 CERAMIC CHIP

1-163-123-00 CERAMIC CHIP
0.001uF
180PF
10%
5%
50V
50V
5%
< CONNECTOR >
< TRANSFORMER >
CN101
CN102
1-778-874-11 CONNECTOR,FFC (LIF(NON-ZIF)) 19P

1-777-937-11 CONNECTOR, FFC/FPC 16P
T621
1-423-980-11 TRANSFORMER, BIAS OSCILLATION
************************************************************
A-4724-486-A BD BOARD, COMPLETE
******************
Remark
25V
50V
25V
16V
50V
< FERRITE BEAD >

FB101
FB103
1-500-445-21 FERRITE
1-500-445-21 FERRITE
< CAPACITOR >
0uH
0uH
< IC >
C101
C102
C103
C104
C108
1-163-005-11
1-164-004-11
1-163-005-11
1-163-009-11
1-164-004-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
470PF
0.1uF
470PF
0.001uF
0.1uF
10%
10%
10%
10%
10%
50V
25V
50V
50V
25V
IC101
IC102
IC103
C109
C110
C111
C112
C113
1-163-011-11
1-164-182-11
1-163-251-11
1-163-038-00
1-163-038-00
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.0015uF 10%
0.0033uF 10%
100PF
5%
0.1uF
0.1uF
50V
50V
50V
25V
25V
Q101
C114
C115
C116
C117
C118
1-163-038-00
1-126-607-11
1-126-607-11
1-126-209-11
1-163-009-11
CERAMIC CHIP
ELECT CHIP
ELECT CHIP
ELECT CHIP
CERAMIC CHIP
0.1uF
47uF
47uF
100uF
0.001uF
25V
4V
4V
4V
50V
C119
C121
C122
C123
C124
1-163-235-11
1-163-038-00
1-126-206-11
1-163-021-11
1-107-823-11
CERAMIC CHIP
CERAMIC CHIP
ELECT CHIP
CERAMIC CHIP
CERAMIC CHIP
22PF
0.1uF
100uF
0.01uF
0.47uF
C125
C126
C127
C128
C129
1-163-038-00
1-163-038-00
1-128-065-11
1-163-038-00
1-163-031-11
CERAMIC CHIP
CERAMIC CHIP
ELECT CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1uF
0.1uF
68uF
0.1uF
0.01uF
C130
C131
C133
C140
C141
1-164-346-11
1-124-779-00
1-164-346-11
1-164-346-11
1-164-346-11
CERAMIC CHIP
ELECT CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
1uF
10uF
1uF
1uF
1uF
20%
20%
20%
10%
5%
20%
10%
10%
20%
20%
50V
25V
6.3V
50V
16V
25V
25V
10V
25V
50V
16V
16V
16V
16V
16V
8-752-386-85 IC CXD2587Q
8-759-549-28 IC BA5974FP-E2
8-752-085-51 IC CXA2568M-T6
< TRANSISTOR >
8-729-010-08 TRANSISTOR MSB710-R
< RESISTOR >
R101
R102
R103
R104
R105
1-216-077-00
1-216-097-91
1-216-077-00
1-216-085-00
1-216-073-00
METAL CHIP
RES,CHIP
METAL CHIP
METAL CHIP
METAL CHIP
15K
100K
15K
33K
10K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R106
R107
R108
R109
R110
1-216-049-11
1-216-073-00
1-216-061-00
1-216-121-00
1-216-025-00
RES,CHIP
METAL CHIP
METAL CHIP
RES,CHIP
RES,CHIP
1K
10K
3.3K
1M
100
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R111
R113
R114
R116
R117
1-216-121-00
1-216-121-00
1-216-073-00
1-216-001-00
1-216-049-11
RES,CHIP
RES,CHIP
METAL CHIP
METAL CHIP
RES,CHIP
1M
1M
10K
10
1K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R119
R123
R124
R131
R143
1-216-041-00
1-216-073-00
1-216-097-91
1-216-033-00
1-216-103-00
METAL CHIP
METAL CHIP
RES,CHIP
METAL CHIP
METAL CHIP
470
10K
100K
220
180K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R144
R147
1-216-103-00 METAL CHIP

1-216-069-00 METAL CHIP
180K
6.8K
5%
5%
1/10W
1/10W
82


scurit.
BD
CD SW
CONNECTOR
Remark
Ref. No.
R148
R149
R158
1-216-001-00 METAL CHIP

1-216-001-00 METAL CHIP
1-216-111-00 METAL CHIP
10
10
390K
5%
5%
5%
1/10W
1/10W
1/10W
S757
1-762-875-21 SWITCH, KEYBOARD ()
************************************************************
R159
R161
R162
R171
R172
1-216-101-00
1-216-308-00
1-216-101-00
1-216-078-00
1-216-073-00
METAL CHIP
METAL CHIP
METAL CHIP
RES,CHIP
METAL CHIP
150K
4.7
150K
16K
10K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R173
R181
R182
R183
1-216-077-00
1-216-078-00
1-216-073-00
1-216-077-00
METAL CHIP
RES,CHIP
METAL CHIP
METAL CHIP
15K
16K
10K
15K
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
Ref. No.
Part No.
Description
Part No.
LEAF SW
< CONNECTOR >

* CN701
CN702
1-568-946-11 PIN, CONNECTOR 8P

< TRANSISTOR >
Q701
8-729-900-80 TRANSISTOR DTC114ES
< NETWORK RESISTER >
< RESISTOR >
1-233-576-11 RES, CHIP NETWORK 100

1-233-576-11 RES, CHIP NETWORK 100
R703
1-249-435-11 CARBON
33K
5%
1/4W
R704
1-249-429-11 CARBON
10K
5%
1/4W
R705
1-249-417-11 CARBON
1K
5%
1/4W
************************************************************
< SWITCH >

S101
Remark
1-658-575-11 CONNECTOR BOARD

*****************
RN101
RN102
Description
1-572-085-11 SWITCH, LEAF (LIMIT)
A-2007-732-A LEAF SW BOARD, COMPLETE

************************
< VIBRATOR >

< CAPACITOR >
X101
1-767-408-21 VIBRATOR, CRYSTAL (16.9344MHz)
************************************************************
C1001
1-107-716-11 ELECT
A-4417-727-A CD SW BOARD, COMPLETE

**********************
33uF
20%
10V
< CONNECTOR >

CN1001 1-568-860-11 SOCKET, CONNECTOR 17P
< DIODE >

< DIODE >
D751
D752
D753
D754
8-719-056-13
8-719-056-13
8-719-056-13
8-719-063-93
LED
LED
LED
LED
SML79423C-TP15 (DISC 1)
SLR325VC-N-T32 (1/u)
D1001
D1002
8-719-911-19 DIODE 1SS119

8-719-911-19 DIODE 1SS119
< CONNECTOR >
< RESISTOR >

* DM1001 1-784-581-11 HOLDER, CABLE (2.5MM PITCH) 4P
R751
R752
R753
R754
R755
1-249-417-11
1-249-418-11
1-249-420-11
1-249-422-11
1-247-843-11
CARBON
CARBON
CARBON
CARBON
CARBON
1K
1.2K
1.8K
2.7K
3.3K
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
1/4W
R756
R757
R758
R759
R760
1-249-425-11
1-249-427-11
1-247-804-11
1-249-407-11
1-247-804-11
CARBON
CARBON
CARBON
CARBON
CARBON
4.7K
6.8K
75
150
75
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
1/4W
R761
R762
R763
R764
1-249-407-11
1-247-804-11
1-249-407-11
1-249-414-11
CARBON
CARBON
CARBON
CARBON
150
75
150
560
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
< PHOTO INTERRUPTER >

IC1001
IC1002
8-749-014-38 PHOTO INTERRUPTER SG-264

8-749-014-38 PHOTO INTERRUPTER SG-264
< TRANSISTOR >
Q1001
8-729-029-56 TRANSISTOR DTA144ESA

< RESISTOR >
R907
R1001
R1002
R1003
R1004
1-247-879-11
1-249-409-11
1-249-409-11
1-249-414-11
1-247-834-11
CARBON
CARBON
CARBON
CARBON
CARBON
100K
220
220
560
1.3K
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
1/4W
R1005
R1006
R1007
R1008
1-247-818-11
1-247-864-11
1-247-856-00
1-249-417-11
CARBON
CARBON
CARBON
CARBON
300
24K
11K
1K
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
< SWITCH >

S751
S752
S753
S754
S755
1-762-875-21 SWITCH, KEYBOARD (1/u)

1-762-875-21 SWITCH, KEYBOARD
((STANDBY) POWER SAVE DEMO)
1-762-875-21 SWITCH, KEYBOARD (DISC 1)
S756
1-762-875-21 SWITCH, KEYBOARD (DISC SKIP EX-CHANGE)

RV1001 1-241-785-11 RES, ADJ, CARBON 10K
RV1002 1-241-785-11 RES, ADJ, CARBON 10K
83
LEAF SW
Ref. No.
S1001
S1002
S1003
S1004
S1005
MAIN
Part No.
1-570-953-11
1-570-953-11
1-771-333-11
1-771-205-11
1-771-205-11
Description
Remark
Remark
10uF
20%
50V
SWITCH, PUSH (1 KEY) (DECK A PLAY)

SWITCH, PUSH (1 KEY) (DECK B PLAY)
SWITCH, LEAF (DECK A HALF)
SWITCH, LEAF (DECK A 120/70)
SWITCH, LEAF (DECK A REC)
C176
C177
C193
C197
C301
1-136-495-11
1-136-153-00
1-126-964-11
1-164-159-11
1-126-960-11
FILM
FILM
ELECT
CERAMIC
ELECT
0.068uF
0.01uF
10uF
0.1uF
1uF
5%
5%
20%
20%
50V
50V
50V
50V
50V
C302
C303
C304
C305
C306
1-130-479-00
1-136-165-00
1-136-165-00
1-126-964-11
1-126-960-11
MYLAR
FILM
FILM
ELECT
ELECT
0.0047uF
0.1uF
0.1uF
10uF
1uF
5%
5%
5%
20%
20%
50V
50V
50V
50V
50V
C307
C308
C309
C310
C311
1-126-959-11
1-126-964-11
1-137-194-81
1-162-290-31
1-126-964-11
ELECT
ELECT
FILM
CERAMIC
ELECT
0.47uF
10uF
0.47uF
470PF
10uF
20%
20%
5%
10%
20%
50V
50V
50V
50V
50V
C312
C313
C314
C315
C316
1-126-959-11
1-162-294-31
1-126-964-11
1-126-963-11
1-104-665-11
ELECT
CERAMIC
ELECT
ELECT
ELECT
0.47uF
0.001uF
10uF
4.7uF
100uF
20%
10%
20%
20%
20%
50V
50V
50V
50V
10V
C317
C320
C333
C334
C351
1-104-665-11
1-162-290-31
1-162-600-11
1-162-600-11
1-126-960-11
ELECT
CERAMIC
CERAMIC
CERAMIC
ELECT
100uF
470PF
0.0047uF
0.0047uF
1uF
20%
10%
30%
30%
20%
10V
50V
16V
16V
50V
C352
C353
C354
C355
C356
1-130-479-00
1-136-165-00
1-136-165-00
1-126-964-11
1-126-960-11
MYLAR
FILM
FILM
ELECT
ELECT
0.0047uF
0.1uF
0.1uF
10uF
1uF
5%
5%
5%
20%
20%
50V
50V
50V
50V
50V
C357
C358
C359
C382
C390
1-126-959-11
1-126-964-11
1-137-194-81
1-104-665-11
1-126-935-11
ELECT
ELECT
FILM
ELECT
ELECT
0.47uF
10uF
0.47uF
100uF
470uF
20%
20%
5%
20%
20%
50V
50V
50V
10V
6.3V
C391
C392
C393
C394
C396
1-161-494-00
1-126-916-11
1-161-494-00
1-126-925-11
1-126-961-11
CERAMIC
ELECT
CERAMIC
ELECT
ELECT
0.022uF
1000uF
0.022uF
470uF
2.2uF
C397
C410
C411
C412
C432
1-126-961-11
1-126-963-11
1-162-306-11
1-107-717-11
1-104-665-11
ELECT
ELECT
CERAMIC
ELECT
ELECT
C433
C437
C501
C502
C503
1-126-961-11
1-126-968-11
1-126-964-11
1-164-159-11
1-136-165-00
C504
C508
C610
C611
C614
1-126-926-11
1-109-889-11
1-102-953-00
1-102-514-11
1-162-306-11
C616
1-104-665-11 ELECT
A-4426-000-A MAIN BOARD, COMPLETE (GRX70J: EA3)

*********************
Description
1-126-964-11 ELECT

(GRX70: E2, MX, AR)
(GRX70: E3, SP, TW)
A-4419-816-A MAIN BOARD, COMPLETE (RXD80)
(GRX70: TH, AUS)
A-4419-991-A MAIN BOARD, COMPLETE (GRX70J: E3)
Part No.
C175
S1006 1-771-333-11 SWITCH, LEAF (DECK B HALF)

S1008 1-771-205-11 SWITCH, LEAF (DECK B 120/70)
S1009 1-771-205-11 SWITCH, LEAF (DECK B REC)
************************************************************
*
Ref. No.
< SWITCH >
7-685-646-79 SCREW +BVTP 3X8 TYPE2 N-S

< CAPACITOR >
C104
C111
C112
C113
C114
1-164-159-11
1-137-195-11
1-136-158-00
1-136-167-00
1-130-480-00
CERAMIC
FILM
FILM
FILM
MYLAR
0.1uF
0.56uF
0.027uF
0.15uF
0.0056uF
5%
5%
5%
5%
50V
50V
50V
50V
50V
C115
C116
C117
C118
C119
1-136-159-00
1-130-473-00
1-136-153-00
1-162-288-31
1-130-479-00
FILM
MYLAR
FILM
CERAMIC
MYLAR
0.033uF
0.0015uF
0.01uF
330PF
0.0047uF
5%
5%
5%
10%
5%
50V
50V
50V
50V
50V
C120
C121
C122
C123
C124
1-130-477-00
1-126-964-11
1-162-291-31
1-136-169-00
1-136-169-00
MYLAR
ELECT
CERAMIC
FILM
FILM
0.0033uF
10uF
560PF
0.22uF
0.22uF
5%
20%
10%
5%
5%
50V
50V
50V
50V
50V
C125
C131
C132
C135
C141
1-126-964-11
1-104-664-11
1-104-664-11
1-126-964-11
1-126-959-11
ELECT
ELECT
ELECT
ELECT
ELECT
10uF
47uF
47uF
10uF
0.47uF
20%
20%
20%
20%
20%
50V
16V
16V
50V
50V
C161
C162
C163
C164
C165
1-137-195-11
1-136-158-00
1-136-167-00
1-130-480-00
1-136-159-00
FILM
FILM
FILM
MYLAR
FILM
0.56uF
0.027uF
0.15uF
0.0056uF
0.033uF
5%
5%
5%
5%
5%
50V
50V
50V
50V
50V
C166
C167
C168
C169
C170
1-130-473-00
1-136-153-00
1-162-288-31
1-130-479-00
1-130-477-00
MYLAR
FILM
CERAMIC
MYLAR
MYLAR
0.0015uF
0.01uF
330PF
0.0047uF
0.0033uF
5%
5%
10%
5%
5%
50V
50V
50V
50V
50V
C171
C172
C173
C174
1-126-964-11
1-162-291-31
1-136-169-00
1-136-169-00
ELECT
CERAMIC
FILM
FILM
10uF
560PF
0.22uF
0.22uF
20%
10%
5%
5%
50V
50V
50V
50V
84
20%
20%
25V
6.3V
25V
10V
50V
2.2uF
4.7uF
0.01uF
47uF
100uF
20%
20%
20%
20%
20%
50V
50V
16V
50V
10V
ELECT
ELECT
ELECT
CERAMIC
FILM
2.2uF
100uF
10uF
0.1uF
0.1uF
20%
20%
20%
5%
50V
50V
50V
50V
50V
ELECT
ELECT
CERAMIC
CERAMIC
CERAMIC
1000uF
1uF
18PF
22PF
0.01uF
20%
20%
5%
5%
20%
10V
50V
50V
50V
16V
100uF
20%
10V
20%
MAIN
Ref. No.
Part No.
Description
C662
C664
C698
C699
1-162-306-11
1-104-665-11
1-162-306-11
1-104-665-11
CERAMIC
ELECT
CERAMIC
ELECT
C801
Remark
0.01uF
100uF
0.01uF
100uF
20%
20%
20%
20%
16V
10V
16V
10V
1-126-963-11 ELECT
4.7uF
C801
1-128-581-11 ELECT
4.7uF
C802
C803
C804
1-162-290-31 CERAMIC
1-162-282-31 CERAMIC
1-104-665-11 ELECT
470PF
100PF
100uF
20%
50V
(GRX70/GRX70J)
20%
100V
(RXD80)
10%
50V
10%
50V
20%
10V
C807
C808
C809
C810
C811
1-136-495-11
1-136-495-11
1-128-560-11
1-128-578-11
1-162-306-11
FILM
FILM
ELECT
ELECT
CERAMIC
0.068uF
0.068uF
22uF
1uF
0.01uF
5%
5%
20%
20%
20%
C812
C841
1-162-306-11 CERAMIC
1-127-811-11 ELECT
0.01uF
3300uF
C842
1-127-752-11 ELECT
3300uF
C842
1-127-814-11 ELECT
3300uF
C843
1-136-165-00 FILM
0.1uF
20%
16V
20%
50V
(GRX70/GRX70J)
20%
63V
(RXD80)
20%
80V
(GRX70/GRX70J)
5%
50V
(GRX70/GRX70J)
C844
C851
1-130-777-00 FILM
1-126-963-11 ELECT
0.1uF
4.7uF
C851
1-128-581-11 ELECT
4.7uF
C852
C853
1-162-290-31 CERAMIC
1-162-282-31 CERAMIC
470PF
100PF
10%
100V
20%
50V
(GRX70/GRX70J)
20%
100V
(RXD80)
10%
50V
10%
50V
C854
C857
C858
C859
C881
1-104-665-11
1-136-495-11
1-136-495-11
1-128-560-11
1-126-967-11
ELECT
FILM
FILM
ELECT
ELECT
100uF
0.068uF
0.068uF
22uF
47uF
20%
5%
5%
20%
20%
C891
1-127-811-11 ELECT
3300uF
C892
1-127-752-11 ELECT
3300uF
C892
1-127-814-11 ELECT
3300uF
C893
1-136-165-00 FILM
0.1uF
C894
1-130-777-00 FILM
0.1uF
20%
50V
(GRX70/GRX70J)
20%
63V
(RXD80)
20%
80V
(GRX70/GRX70J)
5%
50V
(GRX70/GRX70J)
10%
100V
C901
C902
1-136-165-00 FILM
1-126-936-11 ELECT
0.1uF
3300uF
5%
20%
C902
1-126-937-11 ELECT
4700uF
C903
C904
1-126-933-11 ELECT
1-104-664-11 ELECT
100uF
47uF
50V
16V
(RXD80)
20%
16V
(GRX70/GRX70J)
20%
16V
20%
16V
C905
C906
C907
C909
C910
1-104-665-11
1-136-165-00
1-128-548-11
1-126-964-11
1-104-665-11
ELECT
FILM
ELECT
ELECT
ELECT
100uF
0.1uF
4700uF
10uF
100uF
20%
5%
20%
20%
20%
10V
50V
25V
50V
10V
C911
C912
1-126-964-11 ELECT
1-126-926-11 ELECT
10uF
1000uF
20%
20%
50V
10V
50V
50V
100V
100V
16V
Ref. No.
Part No.
Description
Remark
C913
C914
C915
1-126-964-11 ELECT
1-126-767-11 ELECT
1-104-664-11 ELECT
10uF
1000uF
47uF
20%
20%
20%
50V
16V
16V
C916
C917
C951
C952
C953
1-162-306-11
1-126-933-11
1-136-165-00
1-126-768-11
1-126-933-11
0.01uF
100uF
0.1uF
2200uF
100uF
20%
20%
5%
20%
20%
16V
16V
50V
16V
16V
C955
C956
1-104-665-11 ELECT
1-136-165-00 FILM
100uF
0.1uF
20%
5%
10V
50V
CERAMIC
ELECT
FILM
ELECT
ELECT
< CONNECTOR >

CN303
CN304
CN371
CN371
CN391
CN392
CN393
* CN403
CN501
1-784-776-11 CONNECTOR, FFC 15P

(GRX70: E2, TH, MX, AR/RXD80)
(GRX70: E3, SP, TW, AUS/GRX70J)
1-785-334-11
1-785-335-11
1-564-518-11
1-784-784-11
PIN, CONNECTOR (LIGHT ANGLE) 8P

PLUG, CONNECTOR 3P
CONNECTOR, FFC 23P
< DIODE >
10V
50V
50V
100V
50V
D141
D191
D331
D333
D334
8-719-911-19
8-719-911-19
8-719-911-19
8-719-911-19
8-719-911-19
DIODE
DIODE
DIODE
DIODE
DIODE
1SS119
1SS119
1SS119
1SS119
1SS119
D335
D401
D403
D405
D406
8-719-911-19
8-719-911-19
8-719-911-19
8-719-024-99
8-719-024-99
DIODE
DIODE
DIODE
DIODE
DIODE
1SS119
1SS119
1SS119
11ES2-NTA2B
11ES2-NTA2B
D407
D411
D501
D502
D503
8-719-024-99
8-719-911-19
8-719-024-99
8-719-911-19
8-719-911-19
DIODE
DIODE
DIODE
DIODE
DIODE
11ES2-NTA2B
1SS119
11ES2-NTA2B
1SS119
1SS119
D504
D505
D506
D509
D607
8-719-911-19
8-719-911-19
8-719-911-19
8-719-911-19
8-719-911-19
DIODE
DIODE
DIODE
DIODE
DIODE
1SS119
1SS119
1SS119
1SS119
1SS119
D644
D801
D802
D803
D831
8-719-911-19
8-719-911-19
8-719-160-64
8-719-911-19
8-719-302-38
DIODE
DIODE
DIODE
DIODE
DIODE
1SS119
1SS119
RD16F-B1
1SS119
RBV-602-01
D832
D851
D852
D881
D901
8-719-302-38
8-719-911-19
8-719-160-64
8-719-911-19
8-719-024-99
DIODE
DIODE
DIODE
DIODE
DIODE
RBV-602-01 (GRX70/GRX70J)
1SS119
RD16F-B1
1SS119
11ES2-NTA2B
D902
D903
D904
8-719-024-99 DIODE 11ES2-NTA2B

8-719-024-99 DIODE 11ES2-NTA2B
8-719-024-99 DIODE 11ES2-NTA2B
85
MAIN
Ref. No.
Part No.
Description
Remark
D905
D906
8-719-933-36 DIODE HZS6B1L

8-719-911-19 DIODE 1SS119
D907
D908
D909
D910
D915
8-719-024-99
8-719-024-99
8-719-024-99
8-719-024-99
8-719-935-69
DIODE
DIODE
DIODE
DIODE
DIODE
11ES2-NTA2B
11ES2-NTA2B
11ES2-NTA2B
11ES2-NTA2B
HZS11B1LTA
D921
D922
D923
D924
D925
8-719-911-19
8-719-911-19
8-719-911-19
8-719-024-99
8-719-024-99
DIODE
DIODE
DIODE
DIODE
DIODE
1SS119 (GRX70/GRX70J)
11ES2-NTA2B (GRX70/GRX70J)
11ES2-NTA2B (GRX70/GRX70J)
< FERRITE BEAD >

FB301
FB302
1-412-473-21 FERRITE
1-412-473-21 FERRITE
0uH
0uH
< IC >
IC101
IC301
IC381
IC501
IC502
8-759-571-54
8-759-495-26
8-749-923-04
8-759-588-89
8-759-635-63
IC
IC
IC
IC
IC
M62493FP
HA12215
TOTX178 (CD DIGITAL OUT OPTICAL)
M30622MA-A07FP
M51943BSL
IC801
IC801
IC901
IC902
IC903
8-749-015-37
8-749-015-45
8-759-604-86
8-759-231-53
8-759-088-08
IC
IC
IC
IC
IC
STK411-240E (GRX70/GRX70J)
STK407-090E (RXD80)
M5F7807L
TA7805S
uPC7812AHF
< JACK >

J101
J191
1-774-411-11 JACK, PIN 6P (VIDEO (AUDIO) IN, MD IN/OUT)

1-774-785-11 JACK, PIN 1P (SUPER WOOFER)
< COIL >
L381
L392
L501
1-410-521-11 INDUCTOR
1-410-521-11 INDUCTOR
1-410-509-11 INDUCTOR
100uH
100uH
10uH
< TRANSISTOR >

Q111
Q112
Q113
Q161
Q162
8-729-119-78
8-729-119-78
8-729-141-30
8-729-119-78
8-729-119-78
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
2SC403SP-51
2SC403SP-51
2SC3623A-LK
2SC403SP-51
2SC403SP-51
Q163
Q191
Q192
Q201
Q251
8-729-141-30
8-729-141-30
8-729-900-63
8-729-900-36
8-729-900-36
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
2SC3623A-LK
2SC3623A-LK
DTA124ES
DTC124ES
DTC124ES
Q331
Q332
Q333
Q334
Q335
8-729-118-00
8-729-900-80
8-729-118-00
8-729-900-80
8-729-900-80
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
2SB1116-L
DTC114ES
2SB1116-L
DTC114ES
DTC114ES
Q336
Q337
Q338
Q339
8-729-116-59
8-729-045-21
8-729-422-57
8-729-900-80
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
2SB1068TP
2SD1513TP-LK
UN4111
DTC114ES
Ref. No.
Part No.
Description
Remark
Q340
8-729-116-59 TRANSISTOR 2SB1068TP
Q341
Q342
Q343
Q401
Q402
8-729-045-21
8-729-422-57
8-729-900-80
8-729-119-77
8-729-111-29
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
2SD1513TP-LK
UN4111
DTC114ES
2SA1175-FEK
2SD1616A-K
Q411
Q412
Q431
Q432
Q433
8-729-141-30
8-729-900-63
8-729-140-84
8-729-140-82
8-729-140-84
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
2SC3623A-LK
DTA124ES
2SC1841-PAFAEA
2SA988-PAFAEA
2SC1841-PAFAEA
Q434
Q435
Q436
Q437
Q439
8-729-140-84
8-729-900-36
8-729-119-77
8-729-119-79
8-729-119-79
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
2SC1841-PAFAEA
DTC124ES
2SA1175-FEK
2SC2785-FEK
2SC2785-FEK
Q471
Q501
Q508
Q509
Q801
8-729-141-30
8-729-119-78
8-729-900-63
8-729-900-63
8-729-140-84
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
2SC3623A-LK
2SC403SP-51
DTA124ES
DTA124ES
2SC1841-PAFAEA
Q803
Q804
Q831
Q832
Q851
8-729-140-82
8-729-140-84
8-729-140-84
8-729-119-79
8-729-140-84
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
2SA988-PAFAEA
2SC1841-PAFAEA
2SC1841-PAFAEA
2SC2785-FEK
2SC1841-PAFAEA
Q881
Q901
Q902
Q903
Q904
8-729-140-84
8-729-209-15
8-729-119-78
8-729-900-36
8-729-900-36
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
2SC1841-PAFAEA
2SD2012
2SC403SP-51
DTC124ES
DTC124ES
Q905
Q907
Q908
Q909
Q913
8-729-040-20
8-729-040-20
8-729-900-36
8-729-026-68
8-729-119-78
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
RT1P137L-TP
RT1P137L-TP
DTC124ES
2SD2525 (TP)
2SC403SP-51
Q914
Q923
Q951
Q952
8-729-119-77
8-729-900-36
8-729-141-83
8-729-119-77
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
2SA1175-FEK
DTC124ES
2SB1094-LK
2SA1175-FEK
< RESISTOR >

R101
R102
R103
R111
R112
1-249-417-11
1-249-417-11
1-249-417-11
1-249-429-11
1-247-895-00
CARBON
CARBON
CARBON
CARBON
CARBON
1K
1K
1K
10K
470K
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
1/4W
R113
R114
R115
R116
R117
1-247-894-11
1-249-415-11
1-249-433-11
1-247-887-00
1-249-429-11
CARBON
CARBON
CARBON
CARBON
CARBON
430K
680
22K
220K
10K
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
1/4W
R118
R119
R120
R121
R124
1-249-437-11
1-249-421-11
1-249-441-11
1-249-429-11
1-249-421-11
CARBON
CARBON
CARBON
CARBON
CARBON
47K
2.2K
100K
10K
2.2K
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
1/4W
86
MAIN
Ref. No.
Part No.
Description
R125
R126
R130
R131
R132
1-247-843-11
1-249-421-11
1-249-433-11
1-247-807-31
1-247-807-31
CARBON
CARBON
CARBON
CARBON
CARBON
3.3K
2.2K
22K
100
100
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
1/4W
Remark
R133
R141
R142
R143
R144
1-247-807-31
1-249-433-11
1-249-433-11
1-249-417-11
1-249-441-11
CARBON
CARBON
CARBON
CARBON
CARBON
100
22K
22K
1K
100K
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
1/4W
R145
R151
R152
R153
R161
1-247-903-00
1-249-417-11
1-249-417-11
1-249-417-11
1-249-429-11
CARBON
CARBON
CARBON
CARBON
CARBON
1M
1K
1K
1K
10K
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
1/4W
R162
R163
R164
R165
R166
1-247-895-00
1-247-894-11
1-249-415-11
1-249-433-11
1-247-887-00
CARBON
CARBON
CARBON
CARBON
CARBON
470K
430K
680
22K
220K
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
1/4W
R167
R168
R169
R170
R171
1-249-429-11
1-249-437-11
1-249-421-11
1-249-441-11
1-249-429-11
CARBON
CARBON
CARBON
CARBON
CARBON
10K
47K
2.2K
100K
10K
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
1/4W
R178
R190
R196
R197
R198
1-249-421-11
1-249-441-11
1-249-417-11
1-249-441-11
1-249-417-11
CARBON
CARBON
CARBON
CARBON
CARBON
2.2K
100K
1K
100K
1K
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
1/4W
R199
R201
R202
R251
R252
1-249-429-11
1-247-888-11
1-247-903-00
1-247-888-11
1-247-903-00
CARBON
CARBON
CARBON
CARBON
CARBON
10K
240K
1M
240K
1M
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
1/4W
R301
R302
R303
R304
R305
1-249-435-11
1-249-421-11
1-247-807-31
1-247-807-31
1-249-421-11
CARBON
CARBON
CARBON
CARBON
CARBON
33K
2.2K
100
100
2.2K
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
1/4W
R306
R307
R308
R309
R311
1-249-428-11
1-249-428-11
1-249-425-11
1-249-433-11
1-247-903-00
CARBON
CARBON
CARBON
CARBON
CARBON
8.2K
8.2K
4.7K
22K
1M
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
1/4W
R312
R313
R315
R316
R317
1-247-884-11
1-249-441-11
1-249-429-11
1-249-432-11
1-249-429-11
CARBON
CARBON
CARBON
CARBON
CARBON
160K
100K
10K
18K
10K
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
1/4W
R318
R319
R321
R322
R324
1-249-429-11
1-247-893-11
1-249-422-11
1-249-428-11
1-247-876-11
CARBON
CARBON
CARBON
CARBON
CARBON
10K
390K
2.7K
8.2K
75K
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
1/4W
R325
R326
R327
1-247-876-11 CARBON
1-249-437-11 CARBON
1-249-437-11 CARBON
75K
47K
47K
5%
5%
5%
1/4W
1/4W
1/4W
Ref. No.
Part No.
Description
Remark
R328
R329
1-249-437-11 CARBON
1-249-417-11 CARBON
47K
1K
5%
5%
1/4W
1/4W
R330
R331
R332
R333
R334
1-249-425-11
1-249-425-11
1-249-415-11
1-249-421-11
1-249-415-11
CARBON
CARBON
CARBON
CARBON
CARBON
4.7K
4.7K
680
2.2K
680
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
1/4W
R335
R336
R337
R338
R339
1-249-421-11
1-249-437-11
1-249-417-11
1-249-411-11
1-249-437-11
CARBON
CARBON
CARBON
CARBON
CARBON
2.2K
47K
1K
330
47K
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
1/4W
R340
R341
R342
R343
R351
1-249-437-11
1-249-411-11
1-249-437-11
1-249-417-11
1-249-435-11
CARBON
CARBON
CARBON
CARBON
CARBON
47K
330
47K
1K
33K
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
1/4W
R352
R353
R354
R355
R356
1-249-421-11
1-247-807-31
1-247-807-31
1-249-421-11
1-249-428-11
CARBON
CARBON
CARBON
CARBON
CARBON
2.2K
100
100
2.2K
8.2K
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
1/4W
R357
R358
R359
R391
R392
1-249-428-11
1-249-425-11
1-249-435-11
1-247-807-31
1-247-807-31
CARBON
CARBON
CARBON
CARBON
CARBON
8.2K
4.7K
33K
100
100
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
1/4W
R393
R394
R406
R407
R408
1-249-435-11
1-249-435-11
1-249-437-11
1-249-437-11
1-249-425-11
CARBON
CARBON
CARBON
CARBON
CARBON
33K
33K
47K
47K
4.7K
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
1/4W
5%
5%
5%
R409
R410
! R411
1-249-441-11 CARBON
1-249-421-11 CARBON
1-215-893-11 METAL OXIDE
100K
2.2K
1.5K
! R411
2.2K
R413
1-249-402-11 CARBON
56
1/4W
1/4W
2W
F
(RXD80)
5%
2W
F
(GRX70/GRX70J)
5%
1/4W
R414
R415
R416
R417
R421
1-249-417-11
1-249-429-11
1-249-437-11
1-249-417-11
1-260-089-11
CARBON
CARBON
CARBON
CARBON
CARBON
1K
10K
47K
1K
150
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
1/2W
R422
R431
R432
R434
R435
1-260-089-11
1-249-438-11
1-249-437-11
1-249-433-11
1-249-435-11
CARBON
CARBON
CARBON
CARBON
CARBON
150
56K
47K
22K
33K
5%
5%
5%
5%
5%
1/2W
1/4W
1/4W
1/4W
1/4W
R437
R438
R439
R440
R441
1-249-429-11
1-249-429-11
1-249-425-11
1-249-433-11
1-249-435-11
CARBON
CARBON
CARBON
CARBON
CARBON
10K
10K
4.7K
22K
33K
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
1/4W
R443
R471
R472
R473
1-249-417-11
1-260-089-11
1-260-089-11
1-249-402-11
CARBON
CARBON
CARBON
CARBON
1K
150
150
56
5%
5%
5%
5%
1/4W
1/2W
1/2W
1/4W
87


scurit.
portant le nemro spcifi.
MAIN
Ref. No.
Part No.
Description
Remark
R474
1-249-417-11 CARBON
1K
5%
1/4W
R481
R482
R483
R484
R501
1-260-089-11
1-260-089-11
1-260-089-11
1-260-089-11
1-249-413-11
CARBON
CARBON
CARBON
CARBON
CARBON
150
150
150
150
470
5%
5%
5%
5%
5%
1/2W
1/2W
1/2W
1/2W
1/4W
R502
R503
R504
R505
R508
1-249-425-11
1-249-437-11
1-249-437-11
1-249-429-11
1-249-421-11
CARBON
CARBON
CARBON
CARBON
CARBON
4.7K
47K
47K
10K
2.2K
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
1/4W
R509
R521
R522
R523
1-249-441-11
1-249-425-11
1-249-411-11
1-249-421-11
CARBON
CARBON
CARBON
CARBON
100K
4.7K
330
2.2K
R523
1-249-425-11 CARBON
R524
1-247-843-11 CARBON
3.3K
R524
1-249-411-11 CARBON
330
R524
1-249-425-11 CARBON
4.7K
R527
R536
1-249-429-11 CARBON
1-249-429-11 CARBON
10K
10K
R550
R551
R567
R568
R569
1-247-843-11
1-249-429-11
1-247-807-31
1-249-429-11
1-249-429-11
CARBON
CARBON
CARBON
CARBON
CARBON
3.3K
10K
100
10K
10K
5%
5%
5%
5%
5%
R570
R571
R577
R610
R617
1-249-429-11
1-249-429-11
1-249-429-11
1-247-891-00
1-249-429-11
CARBON
CARBON
CARBON
CARBON
CARBON
10K
10K
10K
330K
10K
R618
R619
R622
R626
R627
1-247-807-31
1-247-807-31
1-249-425-11
1-247-807-31
1-247-807-31
CARBON
CARBON
CARBON
CARBON
CARBON
R629
R630
R632
R633
R635
1-247-807-31
1-247-807-31
1-247-807-31
1-247-807-31
1-249-413-11
R636
R637
R639
R642
R643
Ref. No.
Part No.
Description
Remark
R656
R657
R658
1-247-807-31 CARBON
1-247-807-31 CARBON
1-249-417-11 CARBON
100
100
1K
5%
5%
5%
1/4W
1/4W
1/4W
R659
R660
R661
R663
R665
1-247-807-31
1-247-807-31
1-247-807-31
1-247-807-31
1-247-807-31
CARBON
CARBON
CARBON
CARBON
CARBON
100
100
100
100
100
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
1/4W
R666
R667
R668
R669
R670
1-247-807-31
1-247-807-31
1-247-807-31
1-247-807-31
1-247-807-31
CARBON
CARBON
CARBON
CARBON
CARBON
100
100
100
100
100
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
1/4W
R671
R686
R687
R688
R689
1-247-807-31
1-247-807-31
1-247-807-31
1-247-807-31
1-247-807-31
CARBON
CARBON
CARBON
CARBON
CARBON
100
100
100
100
100
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
1/4W
R690
R691
R801
R802
R803
1-247-807-31
1-247-807-31
1-249-417-11
1-249-438-11
1-247-822-11
CARBON
CARBON
CARBON
CARBON
CARBON
100
100
1K
56K
430
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
1/4W
(GRX70J)
R803
1-249-411-11 CARBON
330
5%
1/4W
1/4W
1/4W
1/4W
1/4W
R803
1-249-414-11 CARBON
560
5%
R804
R805
R806
1-249-438-11 CARBON
1-249-417-11 CARBON
1-249-431-11 CARBON
56K
1K
15K
5%
5%
5%
1/4W
(GRX70)
1/4W
(RXD80)
1/4W
1/4W
1/4W
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
1/4W
R807
! R808
R809
R810
! R811
1-249-441-11
1-220-893-11
1-260-076-11
1-260-105-11
1-212-881-11
CARBON
METAL
CARBON
CARBON
FUSIBLE
100K
0.22
10
3.3K
100
5%
10%
5%
5%
5%
1/4W
5W
1/2W
1/2W
1/4W F
100
100
4.7K
100
100
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
1/4W
! R812
R813
R814
R815
R816
1-202-972-61
1-249-435-11
1-249-421-11
1-249-433-11
1-249-429-11
FUSIBLE
CARBON
CARBON
CARBON
CARBON
1
33K
2.2K
22K
10K
5%
5%
5%
5%
5%
1/4W F
1/4W
1/4W
1/4W
1/4W
CARBON
CARBON
CARBON
CARBON
CARBON
100
100
100
100
470
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
1/4W
R817
R818
R819
R831
R832
1-249-421-11
1-249-435-11
1-249-439-11
1-249-441-11
1-249-441-11
CARBON
CARBON
CARBON
CARBON
CARBON
2.2K
33K
68K
100K
100K
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
1/4W
1-247-807-31
1-249-417-11
1-247-807-31
1-247-807-31
1-247-807-31
CARBON
CARBON
CARBON
CARBON
CARBON
100
1K
100
100
100
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
1/4W
R833
R842
R851
R852
R853
1-249-436-11
1-249-441-11
1-249-417-11
1-249-438-11
1-247-822-11
CARBON
CARBON
CARBON
CARBON
CARBON
39K
100K
1K
56K
430
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
1/4W
(GRX70J)
R649
R650
R651
R652
R653
1-247-807-31
1-247-807-31
1-247-807-31
1-247-807-31
1-247-807-31
CARBON
CARBON
CARBON
CARBON
CARBON
100
100
100
100
100
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
1/4W
R853
1-249-411-11 CARBON
330
5%
R853
1-249-414-11 CARBON
560
5%
R654
R655
1-247-807-31 CARBON
1-247-807-31 CARBON
100
100
5%
5%
1/4W
1/4W
R854
R855
R856
1-249-438-11 CARBON
1-249-417-11 CARBON
1-249-431-11 CARBON
56K
1K
15K
5%
5%
5%
1/4W
(GRX70)
1/4W
(RXD80)
1/4W
1/4W
1/4W
5%
1/4W
5%
1/4W
5%
1/4W
5%
1/4W
(GRX70: E2, MX, AR)
4.7K
5%
1/4W
(GRX70: TH, AUS/GRX70J: EA3)
5%
1/4W
(GRX70J: EA3)
5%
1/4W
(GRX70: TH, AUS)
5%
1/4W
(GRX70: E2, MX, AR)
5%
1/4W
5%
1/4W
88


scurit.
MAIN
Ref. No.
Part No.
Description
MOTOR (SLIDE)
Remark
R857
! R858
R859
R860
! R861
1-249-441-11
1-220-893-11
1-260-076-11
1-260-105-11
1-212-881-11
CARBON
METAL
CARBON
CARBON
FUSIBLE
100K
0.22
10
3.3K
100
5%
10%
5%
5%
5%
1/4W
5W
1/2W
1/2W
1/4W F
R881
R882
R892
R901
R902
1-249-435-11
1-249-435-11
1-249-441-11
1-247-843-11
1-249-415-11
CARBON
CARBON
CARBON
CARBON
CARBON
33K
33K
100K
3.3K
680
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
1/4W
R903
R904
R905
R906
R907
1-249-419-11
1-249-414-11
1-249-425-11
1-247-843-11
1-249-415-11
CARBON
CARBON
CARBON
CARBON
CARBON
1.5K
560
4.7K
3.3K
680
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
1/4W
R908
R909
R911
R920
R921
1-249-429-11
1-249-430-11
1-249-409-11
1-249-383-11
1-249-383-11
CARBON
CARBON
CARBON
CARBON
CARBON
10K
12K
220
1.5
1.5
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/6W
1/6W
R931
1-249-429-11 CARBON
10K
5%
1/4W
Ref. No.
D804
D805
Part No.
PANEL
Description
Remark
8-719-911-19 DIODE 1SS119

8-719-911-19 DIODE 1SS119
< IC >
IC801
8-759-274-09 IC BA6286N
< RESISTOR >
R801
1-249-401-11 CARBON
47
5%
1/4W
< SWITCH >

S801
1-762-527-11 SWITCH, ROTARY (OPEN/CLOSE DET)
************************************************************
1-658-577-11 MOTOR (TURN) BOARD
*******************
< CAPACITOR >

C701
C702
C705
1-162-306-11 CERAMIC
1-126-964-11 ELECT
1-162-306-11 CERAMIC
0.01uF
10uF
0.01uF
20%
20%
20%
16V
50V
16V
< CONNECTOR >

CN703
CN703
CN704

RV301
RV351
MOTOR (TURN)
1-238-600-11 RES, ADJ, CARBON 10K

1-238-600-11 RES, ADJ, CARBON 10K

< DIODE >
< RELAY >

D701
RY401
8-719-983-66 DIODE MTZJ-T-72-3.6B
1-755-168-11 RELAY
< IC >
< THERMISTOR >
IC701
TH831
8-759-633-65 IC M54641L
1-807-796-11 THERMISTOR
< RESISTOR >
< TERMINAL >
TM401
1-537-240-31 TERMINAL BOARD (CHECKER PIN)
TM402
(SPEAKER)
1-537-240-31 TERMINAL BOARD (CHECKER PIN)
(SURROUND SPEAKER) (GRX70/GRX70J)
R706
1-249-411-11 CARBON
330
5%
1/4W
R707
1-249-401-11 CARBON
47
5%
1/4W
************************************************************
*
A-4417-808-A PANEL BOARD, COMPLETE (GRX70/RXD80)

A-4419-985-A PANEL BOARD, COMPLETE (GRX70J: E3)
A-4426-002-A PANEL BOARD, COMPLETE (GRX70J: EA3)
**********************
4-214-439-11 HOLDER, FL TUBE
< VIBRATOR >

X601
1-567-098-41 VIBRATOR, CRYSTAL (32.768kHz)
X613
1-781-107-21 VIBRATOR, SERAMIC (16MHz)
************************************************************
< CAPACITOR >

1-658-578-11 MOTOR (SLIDE) BOARD
*******************
< CAPACITOR >

C801
C804
C805
1-162-306-11 CERAMIC
1-162-306-11 CERAMIC
1-126-964-11 ELECT
0.01uF
0.01uF
10uF
< CONNECTOR >

* CN801

< DIODE >
D801
8-719-921-48 DIODE MTZJ-T-72-5.6C
20%
20%
20%
16V
16V
50V
C601
C602
C603
C604
C606
1-124-589-11
1-126-163-11
1-162-306-11
1-164-159-11
1-126-160-11
ELECT
ELECT
CERAMIC
CERAMIC
ELECT
47uF
4.7uF
0.01uF
0.1uF
1uF
20%
20%
20%
20%
16V
50V
16V
50V
50V
C607
C610
C611
C612
C614
1-126-160-11
1-124-589-11
1-162-306-11
1-162-306-11
1-162-306-11
ELECT
ELECT
CERAMIC
CERAMIC
CERAMIC
1uF
47uF
0.01uF
0.01uF
0.01uF
20%
20%
20%
20%
20%
50V
16V
16V
16V
16V
C615
C616
C617
1-162-306-11 CERAMIC
1-126-157-11 ELECT
1-162-303-11 CERAMIC
0.01uF
20%
10uF
20%
0.0033uF 30%
16V
16V
16V
89


scurit.
PANEL
Ref. No.
Part No.
Description
Remark
Ref. No.
Part No.
Description
Remark
C618
C619
1-126-157-11 ELECT
1-126-157-11 ELECT
10uF
10uF
20%
20%
16V
16V
C733
C734
1-162-294-31 CERAMIC
1-162-215-31 CERAMIC
0.001uF
47PF
10%
5%
C620
C625
C627
C628
C630
1-126-163-11
1-126-157-11
1-162-306-11
1-126-157-11
1-162-306-11
ELECT
ELECT
CERAMIC
ELECT
CERAMIC
4.7uF
10uF
0.01uF
10uF
0.01uF
20%
20%
20%
20%
20%
50V
16V
16V
16V
16V
C735
C736
C737
C738
1-124-261-00
1-162-290-31
1-124-463-00
1-124-257-00
10uF
470PF
0.1uF
2.2uF
C739
1-162-215-31 CERAMIC
47PF
20%
50V
10%
50V
20%
50V
20%
50V
(GRX70J: EA3)
5%
50V
C651
C652
C653
C654
C655
1-162-282-31
1-162-282-31
1-162-282-31
1-162-282-31
1-162-282-31
CERAMIC
CERAMIC
CERAMIC
CERAMIC
CERAMIC
100PF
100PF
100PF
100PF
100PF
10%
10%
10%
10%
10%
50V
50V
50V
50V
50V
C741
C742
C743
C747
1-124-261-00
1-162-282-31
1-124-257-00
1-164-159-11
10uF
100PF
2.2uF
0.1uF
C656
C657
C658
C659
C660
1-162-282-31
1-162-282-31
1-162-282-31
1-162-282-31
1-162-282-31
CERAMIC
CERAMIC
CERAMIC
CERAMIC
CERAMIC
100PF
100PF
100PF
100PF
100PF
10%
10%
10%
10%
10%
50V
50V
50V
50V
50V
CN601
C661
C662
C663
C664
C665
1-162-282-31
1-162-282-31
1-162-282-31
1-162-282-31
1-162-282-31
CERAMIC
CERAMIC
CERAMIC
CERAMIC
CERAMIC
100PF
100PF
100PF
100PF
100PF
10%
10%
10%
10%
10%
50V
50V
50V
50V
50V
D610
D611
D612
D613
D614
8-719-050-84
8-719-073-47
8-719-056-13
8-719-058-03
8-719-058-03
DIODE RB441Q-40T-72
LED SML72923C-TP15 (REC PAUSE/START)
LED SML79423C-TP15 (^ CD)
LED SEL5423E-TP15 (( TAPE B)
LED SEL5423E-TP15 (9 TAPE B)
C666
C667
C668
C701
C702
1-162-282-31
1-162-282-31
1-162-282-31
1-162-294-31
1-162-294-31
CERAMIC
CERAMIC
CERAMIC
CERAMIC
CERAMIC
100PF
100PF
100PF
0.001uF
0.001uF
10%
10%
10%
10%
10%
50V
50V
50V
50V
50V
D615
D616
D619
D620
D621
8-719-058-03
8-719-058-03
8-719-057-97
8-719-057-97
8-719-057-97
LED
LED
LED
LED
LED
SEL5423E-TP15 (( TAPE A)
SEL5423E-TP15 (9 TAPE A)
SEL5923A-TP15 (SYNC BASS L)
SEL5923A-TP15 (SYNC BASS H)
SEL5923A-TP15 (SYNC EQ)
C703
C711
1-164-159-11 CERAMIC
1-162-294-31 CERAMIC
0.1uF
0.001uF
C712
1-162-305-11 CERAMIC
D622
D624
D627
D628
D629
8-719-063-93
8-719-063-93
8-719-057-97
8-719-063-93
8-719-063-93
LED
LED
LED
LED
LED
SLR325VC-N-T32 (EFFECT)
SLR325VC-N-T32 (NON-STOP)
SEL5923A-TP15 (GROOVE)
SLR325VC-N-T32 (ENTER/NEXT)
SLR325VC-N-T32 (JOG DIAL)
C713
1-126-160-11 ELECT
C714
1-136-495-11 FILM
D630
D631
D632
D701
8-719-057-97
8-719-057-97
8-719-063-93
8-719-109-85
LED SEL5923A-TP15 (- ))
LED SEL5923A-TP15 (+ 0)
LED SLR325VC-N-T32 (TIMER SELECT)
DIODE RD5.1ES-B2 (GRX70J: EA3)
C715
1-124-465-00 ELECT
0.47uF
C716
1-124-465-00 ELECT
0.47uF
C717
1-136-167-00 FILM
0.15uF
C718
1-162-294-31 CERAMIC
0.001uF
C719
1-126-160-11 ELECT
1uF
C720
1-161-494-00 CERAMIC
0.022uF
C721
1-162-305-11 CERAMIC
C722
1-136-495-11 FILM
C723
1-124-589-11 ELECT
C724
1-136-165-00 FILM
C725
1-124-589-11 ELECT
47uF
C731
C732
1-162-306-11 CERAMIC
1-124-257-00 ELECT
0.01uF
2.2uF
ELECT
CERAMIC
ELECT
ELECT
ELECT
CERAMIC
ELECT
CERAMIC
20%
10%
20%
50V
50V
50V
50V
50V
50V
< CONNECTOR >

< DIODE >
50V
10%
50V
(GRX70J: EA3)
0.0068uF 30%
16V
(GRX70J: EA3)
1uF
20%
50V
(GRX70J: EA3)
0.068uF 5%
50V
(GRX70J: EA3)
20%
50V
(GRX70J: EA3)
20%
50V
(GRX70J: EA3)
5%
50V
(GRX70J: EA3)
10%
50V
(GRX70J: EA3)
20%
50V
(GRX70J: EA3)
< EARTH TERMINAL >

* EP601
1-537-738-21 TERMINAL, EARTH

< FERRITE BEAD >
FB601
FB602
1-412-473-21 FERRITE
1-412-473-21 FERRITE
0uH
0uH
< FLUORESCENT INDICATOR TUBE >

25V
(GRX70J: EA3)
0.0068uF 30%
16V
(GRX70J: EA3)
0.068uF 5%
50V
(GRX70J: EA3)
47uF
20%
16V
(GRX70J: EA3)
0.1uF
5%
50V
(GRX70J: EA3)
20%
16V
(GRX70J: EA3)
20%
16V
20%
50V
FL601
1-517-831-11 INDICATOR TUBE, FLUORESCENT

< IC >
IC601
IC602
IC603
IC604
IC711
8-759-589-13
8-749-011-05
8-759-083-77
8-759-342-19
8-759-496-40
IC712
8-759-636-55 IC M5218AFP
90
IC
IC
IC
IC
IC
TMP88CS76F-6004
GP1U28X
BA3830F
NJU3716M-T2
M65850FP (GRX70J: EA3)
PANEL
Ref. No.
Part No.
Description
Remark
< JACK >

J701
J711
1-785-569-11 JACK (SMALL TYPE) (PHONES)

1-785-569-11 JACK (SMALL TYPE) (MIX MIC)
< COIL >
L601
L602
1-410-509-11 INDUCTOR
1-410-517-11 INDUCTOR
10uH
47uH
< TRANSISTOR >

Q601
Q602
Q603
Q604
Q605
8-729-118-00
8-729-118-00
8-729-119-78
8-729-422-57
8-729-422-57
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
2SB1116-L
2SB1116-L
2SC403SP-51
UN4111
UN4111
Q606
Q607
Q608
Q609
Q610
8-729-900-80
8-729-900-74
8-729-900-74
8-729-900-74
8-729-900-74
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
DTC114ES
DTC143TS
DTC143TS
DTC143TS
DTC143TS
Q611
Q612
Q613
8-729-900-74 TRANSISTOR DTC143TS

< RESISTOR >
R600
R601
R602
R603
R604
1-247-903-00
1-247-807-31
1-249-429-11
1-247-807-31
1-247-807-31
CARBON
CARBON
CARBON
CARBON
CARBON
1M
100
10K
100
100
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
1/4W
R605
R606
R607
R608
R609
1-249-429-11
1-249-401-11
1-247-893-11
1-247-893-11
1-249-441-11
CARBON
CARBON
CARBON
CARBON
CARBON
10K
47
390K
390K
100K
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
1/4W
R610
R611
R612
R613
R614
1-249-429-11
1-249-441-11
1-249-401-11
1-249-435-11
1-247-895-00
CARBON
CARBON
CARBON
CARBON
CARBON
10K
100K
47
33K
470K
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
1/4W
R615
R616
R617
R618
R619
1-249-429-11
1-249-441-11
1-249-441-11
1-249-441-11
1-249-441-11
CARBON
CARBON
CARBON
CARBON
CARBON
10K
100K
100K
100K
100K
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
1/4W
R620
R621
R622
R623
R624
1-249-441-11
1-249-429-11
1-249-410-11
1-249-411-11
1-249-413-11
CARBON
CARBON
CARBON
CARBON
CARBON
100K
10K
270
330
470
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
1/4W
R625
R626
R627
R628
R629
1-249-414-11
1-249-415-11
1-249-417-11
1-249-418-11
1-249-420-11
CARBON
CARBON
CARBON
CARBON
CARBON
560
680
1K
1.2K
1.8K
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
1/4W
R630
R631
R632
1-249-422-11 CARBON
1-247-843-11 CARBON
1-249-425-11 CARBON
2.7K
3.3K
4.7K
5%
5%
5%
1/4W
1/4W
1/4W
Ref. No.
Part No.
Description
Remark
R633
R634
1-249-427-11 CARBON
1-249-429-11 CARBON
6.8K
10K
5%
5%
1/4W
1/4W
R635
R636
R637
R638
R639
1-249-431-11
1-249-429-11
1-249-410-11
1-249-411-11
1-249-413-11
CARBON
CARBON
CARBON
CARBON
CARBON
15K
10K
270
330
470
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
1/4W
R640
R641
R642
R650
R651
1-249-414-11
1-249-415-11
1-249-417-11
1-249-429-11
1-249-410-11
CARBON
CARBON
CARBON
CARBON
CARBON
560
680
1K
10K
270
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
1/4W
R652
R653
R654
R655
R656
1-249-411-11
1-249-413-11
1-249-414-11
1-249-415-11
1-249-429-11
CARBON
CARBON
CARBON
CARBON
CARBON
330
470
560
680
10K
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
1/4W
R657
R658
R659
R660
R661
1-249-410-11
1-249-411-11
1-249-413-11
1-249-414-11
1-249-415-11
CARBON
CARBON
CARBON
CARBON
CARBON
270
330
470
560
680
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
1/4W
R662
R663
R664
R665
R666
1-249-417-11
1-249-418-11
1-249-420-11
1-249-422-11
1-249-417-11
CARBON
CARBON
CARBON
CARBON
CARBON
1K
1.2K
1.8K
2.7K
1K
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
1/4W
R667
R668
R669
R670
R671
1-249-417-11
1-249-441-11
1-249-441-11
1-249-414-11
1-249-437-11
CARBON
CARBON
CARBON
CARBON
CARBON
1K
100K
100K
560
47K
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
1/4W
R672
R673
R674
R675
R676
1-249-417-11
1-249-437-11
1-249-417-11
1-249-437-11
1-249-429-11
CARBON
CARBON
CARBON
CARBON
CARBON
1K
47K
1K
47K
10K
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
1/4W
R678
R679
R680
R681
R682
1-249-407-11
1-249-407-11
1-247-804-11
1-249-407-11
1-247-804-11
CARBON
CARBON
CARBON
CARBON
CARBON
150
150
75
150
75
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
1/4W
R683
R684
R685
R688
R689
1-247-804-11
1-247-804-11
1-247-804-11
1-249-402-11
1-249-402-11
CARBON
CARBON
CARBON
CARBON
CARBON
75
75
75
56
56
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
1/4W
R690
R691
R693
R696
R697
1-249-402-11
1-249-407-11
1-249-407-11
1-249-402-11
1-249-407-11
CARBON
CARBON
CARBON
CARBON
CARBON
56
150
150
56
150
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
1/4W
R698
R699
R700
R701
R702
1-249-407-11
1-247-807-31
1-247-807-31
1-249-429-11
1-249-429-11
CARBON
CARBON
CARBON
CARBON
CARBON
150
100
100
10K
10K
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
1/4W
91
PANEL
Ref. No.
SENSOR
SUB TRANS
Part No.
Description
R703
R704
R705
R710
1-249-429-11
1-249-429-11
1-249-429-11
1-249-401-11
CARBON
CARBON
CARBON
CARBON
10K
10K
10K
47
Remark
R711
1-249-433-11 CARBON
22K
R712
1-249-433-11 CARBON
22K
R713
1-249-433-11 CARBON
22K
R714
1-249-437-11 CARBON
47K
R715
1-249-433-11 CARBON
22K
R716
1-249-431-11 CARBON
15K
R717
1-249-433-11 CARBON
22K
R718
1-249-433-11 CARBON
22K
R719
1-247-881-00 CARBON
120K
R721
R722
1-249-429-11 CARBON
1-249-417-11 CARBON
10K
1K
R723
R724
R725
R726
R727
1-249-441-11
1-249-417-11
1-249-433-11
1-249-429-11
1-249-431-11
CARBON
CARBON
CARBON
CARBON
CARBON
100K
1K
22K
10K
15K
5%
1/4W
5%
1/4W
5%
1/4W
5%
1/4W
5%
1/4W
(GRX70J: EA3)
R728
R729
R731
R732
R733
1-247-885-00
1-247-807-31
1-249-440-11
1-249-437-11
1-249-440-11
CARBON
CARBON
CARBON
CARBON
CARBON
180K
100
82K
47K
82K
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
1/4W
R734
R735
R741
R742
R743
1-249-417-11
1-249-420-11
1-249-421-11
1-249-421-11
1-249-421-11
CARBON
CARBON
CARBON
CARBON
CARBON
1K
1.8K
2.2K
2.2K
2.2K
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
1/4W
Ref. No.
5%
1/4W
5%
1/4W
5%
1/4W
5%
1/4W
(GRX70J: EA3)
5%
1/4W
(GRX70J: EA3)
Part No.
Description
Remark
S622
S623
(REPEAT STEREO/MONO)
(PLAY MODE, DOLBY NR)
S624
5%
1/4W
(GRX70J: EA3)
5%
1/4W
(GRX70J: EA3)
5%
1/4W
(GRX70J: EA3)
5%
1/4W
(GRX70J: EA3)
5%
1/4W
(GRX70J: EA3)
5%
1/4W
(GRX70J: EA3)
5%
1/4W
(GRX70J: EA3)
5%
1/4W
(GRX70J: EA3)
5%
1/4W
5%
1/4W
S625
S626
S627
S628

(EDIT, DIRECTION, TUNER MEMORY)
1-762-875-21 SWITCH, KEYBOARD (REC PAUSE/START)
1-762-875-21 SWITCH, KEYBOARD (HI-DUB)
1-762-875-21 SWITCH, KEYBOARD (CD SYNC)
1-762-875-21 SWITCH, KEYBOARD (LOOP)
S629
S630
S638
S639
S640
1-762-875-21
1-762-875-21
1-762-875-21
1-762-875-21
1-762-875-21
SWITCH, KEYBOARD (DISPLAY)

SWITCH, KEYBOARD (SPECTRUM ANALYZER)
SWITCH, KEYBOARD (TIMER SELECT)
SWITCH, KEYBOARD (P FILE MEMORY)
SWITCH, KEYBOARD (GEQ CONTROL)
S641
S642
S643
S644
S645
1-762-875-21
1-762-875-21
1-762-875-21
1-762-875-21
1-762-875-21
SWITCH, KEYBOARD (FILE SELECT)

SWITCH, KEYBOARD (EFFECT)
SWITCH, KEYBOARD (TUNER BAND)
SWITCH, KEYBOARD (^ CD)
SWITCH, KEYBOARD (p)
S646
S647
S648
S649
S650
1-762-875-21
1-762-875-21
1-762-875-21
1-762-875-21
1-762-875-21
SWITCH, KEYBOARD (( TAPE B)

SWITCH, KEYBOARD (9 TAPE B)
SWITCH, KEYBOARD (( TAPE A)
SWITCH, KEYBOARD (9 TAPE A)
SWITCH, KEYBOARD (FUNCTION)
S651
1-762-875-21 SWITCH, KEYBOARD (CLOCK TIMER SET)

< VIBRATOR >
X601
1-781-312-11 VIBRATOR, CERAMIC (12.5MHz)
************************************************************
1-658-576-11 SENSOR BOARD
*************
< PHOTO INTERRUPTER >

IC702
8-749-924-18 PHOTO INTERRUPTER RPI-1391

< PHOTO REFLECTOR >
IC703
8-749-924-30 PHOTO REFLECTOR GP2S28

< RESISTOR >
RV711
RV712
1-225-739-11 RES, VAR 50K (ECHO LEVEL) (GRX70J: EA3)

1-225-739-11 RES, VAR 50K (MIC LEVEL)
< SWITCH >
S601
S602
S611
S612
S613
1-473-534-11
1-473-392-11
1-762-875-21
1-762-875-21
1-762-875-21
ENCODER, ROTARY (JOG DIAL)

ENCODER, ROTARY (VOLUME)
SWITCH, KEYBOARD (SYNC BASS)
SWITCH, KEYBOARD (SYNC EQ)
SWITCH, KEYBOARD (KARAOKE PON/MPX)
S614
S615
S616
S617
S618
1-762-875-21
1-762-875-21
1-762-875-21
1-762-875-21
1-762-875-21
SWITCH, KEYBOARD (NON-STOP)

SWITCH, KEYBOARD (SURROUND)
SWITCH, KEYBOARD (DBFB)
SWITCH, KEYBOARD (ENTER/NEXT)
SWITCH, KEYBOARD (+ ))
S619
S620
S621
1-762-875-21 SWITCH, KEYBOARD (- 0)

1-762-875-21 SWITCH, KEYBOARD (GROOVE)
1-762-875-21 SWITCH, KEYBOARD (FLASH)
R701
1-249-416-11 CARBON
820
5%
1/4W
R702
1-249-407-11 CARBON
150
5%
1/4W
************************************************************
A-4417-729-A SUB TRANS BOARD, COMPLETE (RXD80)
**************************
< CAPACITOR >

C11
C12
C13
C14
C15
C16
! C21
92
1-126-768-11
1-164-159-11
1-126-933-11
1-126-968-11
1-164-159-11
ELECT
CERAMIC
ELECT
ELECT
CERAMIC
2200uF
0.1uF
100uF
100uF
0.1uF
20%
1-126-948-11 ELECT
1-113-925-11 CERAMIC
100uF
0.01uF
20%
20%

20%
20%
16V
50V
16V
50V
50V
35V
250V

scurit.
SUB TRANS
Ref. No.
Part No.
Description
Remark
Ref. No.
Part No.
Description
Remark
< CAPACITOR >
< CONNECTOR >

CN11
* CN12
CN13
TRANS
! C952
1-162-306-11 CERAMIC
0.01uF
C971
1-128-563-11 ELECT
100uF
< DIODE >
C972
1-126-960-11 ELECT
1uF
C973
1-126-948-11 ELECT
100uF

1-785-333-11 PIN, CONNECTOR (LIGHT ANGLE) 7P
D11
D12
D13
D14
D15
8-719-911-19
8-719-210-21
8-719-210-21
8-719-210-21
8-719-210-21
DIODE
DIODE
DIODE
DIODE
DIODE
1SS119
11EQS04
11EQS04
11EQS04
11EQS04
D16
D17
D18
D19
D20
8-719-911-19
8-719-024-99
8-719-024-99
8-719-024-99
8-719-024-99
DIODE
DIODE
DIODE
DIODE
DIODE
1SS119
11ES2-NTA2B
11ES2-NTA2B
11ES2-NTA2B
11ES2-NTA2B
D21
D22
D23
8-719-986-60 DIODE HZS27-3LTA

8-719-109-63 DIODE RD3.0ESB2
8-719-911-19 DIODE 1SS119
20%
16V
(GRX70J)
20%
100V
(GRX70/GRX70J)
20%
50V
(GRX70/GRX70J)
20%
35V
(GRX70/GRX70J)
< CONNECTOR >

CN951
* CN952
* CN952
CN953
1-564-321-00
1-564-527-11
1-564-524-11
1-785-329-11
PIN, CONNECTOR 2P (GRX70/GRX70J)

PLUG, CONNECTOR 12P (GRX70/GRX70J)
PLUG, CONNECTOR 9P (RXD80)
(GRX70/GRX70J)
< DIODE >
D971
D972
D973
8-719-024-99 DIODE 11ES2-NTA2B (GRX70/GRX70J)

8-719-986-60 DIODE HZS27-3LTA (GRX70/GRX70J)
8-719-109-63 DIODE RD3.0ESB2 (GRX70/GRX70J)
< IC >
< FUSE >
IC11
8-759-450-47 IC BA05T
! F951
! F951
! F961
! F962
! F963
1-532-506-31 FUSE T6.3AL/250V

(GRX70: E2, E3, SP, TW, AR/GRX70J)
1-533-310-11 FUSE, GLASS TUBE 6.3A/125V (RXD80)
1-532-505-31 FUSE T5AL/250V (GRX70/GRX70J)
1-532-505-31 FUSE T5AL/250V (GRX70/GRX70J)
1-532-506-31 FUSE T6.3AL/250V (GRX70/GRX70J)
! F964
1-532-506-31 FUSE T6.3AL/250V (GRX70/GRX70J)
< TRANSISTOR >

Q11
Q12
Q13
Q14
Q15
8-729-119-78
8-729-040-19
8-729-118-01
8-729-040-19
8-729-040-19
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
2SC403SP-51
RT1N137L-TP
2SB1116
RT1N137L-TP
RT1N137L-TP
Q16
Q17
8-729-900-63 TRANSISTOR DTA124ES

8-729-900-63 TRANSISTOR DTA124ES
< TRANSISTOR >

Q971
8-729-048-52 TRANSISTOR 2SA1932 (TP)

(GRX70/GRX70J)
< RESISTOR >

R11
R12
R13
R15
R16
1-249-429-11
1-249-441-11
1-249-417-11
1-249-429-11
1-247-807-31
CARBON
CARBON
CARBON
CARBON
CARBON
10K
100K
1K
10K
100
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
1/4W
R17
R18
R19
R20
R23
1-247-807-31
1-247-807-31
1-249-427-11
1-249-429-11
1-249-427-11
CARBON
CARBON
CARBON
CARBON
CARBON
100
100
6.8K
10K
6.8K
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
1/4W
< RESISTOR >
< RELAY >

! RY11
1-755-276-11 RELAY, POWER
! R951
1-219-120-11 FUSIBLE
0.15
! R951
1-219-122-91 FUSIBLE
0.33
! R952
1-219-122-91 FUSIBLE
0.33
! R952
1-219-120-11 FUSIBLE
0.15
! R953
1-219-119-81 FUSIBLE
0.1
1/4W F
(RXD80)
5%
1/4W F
(GRX70/GRX70J)
5%
1/4W F
(RXD80)
5%
1/4W F
(GRX70/GRX70J)
5%
1/4W F
! R961
1-202-725-00 SOLID
3.3M
10%
!R971
820
< TRANSFORMER >
R972
1-249-429-11 CARBON
10K
! T11
1-433-587-11 TRANSFORMER, POWER
************************************************************
R973
1-249-429-11 CARBON
10K
R974
1-247-807-31 CARBON
100
R975
1-247-807-31 CARBON
100
1-672-369-11 TRANS BOARD

************************
1-533-217-31 HOLDER, FUSE
93

5%
1/2W
(RXD80)
5%
2W
F
(GRX70/GRX70J)
5%
1/4W
(GRX70/GRX70J)
5%
1/4W
(GRX70/GRX70J)
5%
1/4W
(GRX70/GRX70J)
5%
1/4W
(GRX70/GRX70J)

scurit.
TRANS
Ref. No.
Part No.
Description
Remark
Ref. No.
Part No.
< SWITCH >

!S951
! T951
! T951
************************************************************
MISCELLANEOUS
**************
64
104
104
105
106
109
109
110
110
110
110
110
! 111
! 111
! 111
! 111
! 111
! 112
! 112
257

(GRX70: E3, TW, AR, AUS/RXD80)
(GRX70: E2, SP, TH, MX/GRX70J)
#1
#2
#3
#4
#5
7-685-872-09
7-685-646-79
7-685-871-01
7-685-647-79
7-685-852-04
SCREW +BVTT 3X8 (S)

SCREW +BVTP 3X8 TYPE2 N-S
SCREW +BVTT 3X6 (S)
SCREW +BVTP 3X10 TYPE2 N-S
SCREW +BVTT 2X5 (S)
#6
#7
#8
#9
#10
7-685-861-01
7-685-851-04
7-621-775-10
7-685-650-79
7-685-880-09
SCREW +BVTT 2.6X5 (S)

SCREW +BVTT 2X4 (S)
SCREW +B 2.6X4
SCREW +BVTP 3X16 TYPE2 IT-3
SCREW +BVTT 4X6 (S)
#11
#12
7-628-254-15 SCREW +PS 2.6X6

7-628-254-50 SCREW +PS 2.6X16

(GRX70: E2, TH, MX, AR, AUS/ RXD80)
1-233-544-14 TUNER PACK (RXD80)
1-233-545-11 TUNER (FM/AM) (GRX70: TH, AUS)
1-233-545-14 TUNER PACK (GRX70: MX, AR)
1-233-546-11 TUNER (FM/MW/SW) (GRX70: E3, SP, TW/
GRX70J)
1-693-453-11 TUNER (FM/AM) (GRX70: E2)
1-575-651-11 CORD, POWER (GRX70: SP, TW/GRX70J: EA3)
1-575-653-11 CORD, POWER (GRX70: E2, E3, TH, MX/
GRX70J: E3)
1-690-608-11 CORD, POWER (GRX70: AUS)
1-690-609-21 CORD, POWER (RXD80: CND)
1-783-941-21 CORD, POWER (GRX70: AR)
(GRX70: E3/GRX70J: E3)
1-452-925-21 MAGNET ASSY
258
1-776-042-11
! 301
8-820-020-02
302
1-769-069-11
HP101 A-2056-681-A
HRPE101A-2056-682-A
M1
M101
M102
M501
M701
Remark
**************
HARDWARE LIST
**************
1-771-291-11 SWITCH, POWER (VOLTAGE SELECTOR)

(GRX70: E2, E3, SP, TW, AR/GRX70J)
< TRANSFORMER >
Description
A-2004-628-A
X-4917-523-4
X-4917-504-1
1-698-792-11
A-4672-004-A

OPTICAL PICK-UP KSS-213D/Q-NP
DECK (A) ASSY, HEAD
DECK (B) ASSY, HEAD
MOTOR ASSY, CAPSTAN
MOTOR ASSY (SPINDLE)
MOTOR ASSY (SLED)
FAN, DC
MOTOR ASSY (DISC TRAY TURN)
M801
A-4672-004-A MOTOR ASSY (DISC TRAY SLIDE)
S811
1-473-335-11 ENCODER, ROTARY (BU, TRAY ADDRESS DET)
! T11
! T951
!T951
************************************************************
Sony Corporation
9-928-843-11
Home A&V Products Company
94

scurit.
99D057030-1
Printed in Singapore 1999. 4
Published by Quality Assurance Dept.
(Shinagawa)

HCD-GRX70 (9-928-843-11) PDF

Uploaded by

Copyright:

Available Formats

HCD-GRX70 (9-928-843-11) PDF

Uploaded by

Document Information

Original Title

Copyright

Available Formats

Share this document

Share or Embed Document

Sharing Options

Did you find this document useful?

Is this content inappropriate?

Copyright:

Available Formats

HCD-GRX70 (9-928-843-11) PDF

Uploaded by

Copyright:

Available Formats

HCD-GRX70/GRX70J/RXD80

HCD-GRX70/GRX70J/RXD80 are the Amplifier, CD player, Tape Deck and Tuner

Photo: HCD-GRX70 (GRAY)

Dolby noise reduction manufactured under license

Model Name Using Similar Mechanism

Base Unit Name

Optical Pick-up Name

Model Name Using Similar Mechanism

voltage 450 mV/250 mV,

MINI Hi-Fi COMPONENT SYSTEM

Compact disc and digital audio system

4-track 2-channel stereo

Approx. 280 340 395 mm

Design and specifications are subject to change without notice.

87.5 - 108.0 MHz

UKV tuner section (3 band (FM-AM-UKV) models only)

SAFETY-RELATED COMPONENT WARNING!!

SERVICING NOTES ............................................... 3

NOTES ON HANDLING THE OPTICAL PICK-UP

TEST MODE .............................................................. 11

MECHANICAL ADJUSTMENTS ....................... 14

NOTES ON LASER DIODE EMISSION CHECK

Location of Controls ....................................................... 6

DECK Section ................................................................. 14

Block Diagram CD SERVO Section ........................

EXPLODED VIEWS ................................................ 72

ELECTRICAL PARTS LIST ............................... 81

The laser beam on this model is concentrated so as to be focused

This appliance is classified as a CLASS 1 LASER product.

Laser component in this product is capable of emitting radiation

USYNLIG LASERSTRLING VED BNING NR

VORSICHT : UNSICHTBARE LASERSTRAHLUNG, WENN

Argentine and 120 V AC Area in E models

Saudi Arabia model

GRX70J: 240 V AC Area in E model

GRX70: 240 V AC Area in E model

3 Pull-out the disc tray.

NOTE FOR INSTALLATION (ROTARY ENCODER)

Note:When attaching the BU cam,

This section is extracted from

@ EDIT, DIRECTION, TUNER MEMORY

LOADING PANEL ASSY

FRONT PANEL SECTION

1 wire (flat type)

1 wire (flat type)

CD MECHANISM DECK SECTION (CDM38LH-5BD32L)

5 wire (flat type) (19 core)

TAPE MECHANISM DECK SECTION (TCM-230AWR2)

4 tape mechanism deck section

1 Push the cassette lid.

1 wire (flat type)

6 Remove the MAIN board

[CD Service Mode]

[Change-over the AM Tuning Interval]

Turn the disc tray

Display at an error occurred

2) Display of mechanical error

3) Display of no disc error

Play track1 for 2 seconds