SL4635 & SL4835 Parts Manual

Form No.
907807
SL4635/4835
Skid Steer
Loaders
PARTS BOOK
Introduction NOTE: The following abbreviations may be
used herein:
For your safety and continued proper operation, use
only genuine GEHL® service parts. When ordering AMP . . . . . . . Ampere
service parts, specify the correct part number, full AR . . . . . . . . As Required
description, quantity required, the unit model number ASSY . . . . . . Assembly
and serial number.
CCA . . . . . . . Cold Cranking Amperage
The model and serial numbers for this unit are on a CYL . . . . . . . Cylinder
decal located inside the right chassis riser, between FRT . . . . . . . Front
the lift arm and inner riser. “Right” and “Left” are
FL . . . . . . . . Flare
determined from a position sitting on the seat and
facing forward. GA . . . . . . . . Gauge
HEX . . . . . . . Hexagon
GEHL Company reserves the right to make changes
JIC . . . . . . . . Joint Industrial Council
or improvements in the design or construction of any
part of the unit without incurring the obligation to kW . . . . . . . . Kilowatt
install such changes on any previously delivered LBS . . . . . . . Pounds
units. LT . . . . . . . . Left
NOTE: Purchase equivalent, quality tires for M. . . . . . . . . Metric
your loader. Contact your dealer for replacement MM (mm) . . . . Millimeter
tire information. NA . . . . . . . . Naturally Aspirated
NOTE: Replacement batteries are not pro- N/A . . . . . . . Not Applicable
vided by the GEHL Company. For battery speci- NEG . . . . . . . Negative
fications see pages titled “Electrical Engine NILN. . . . . . . Nylon Insert Lock Nut
Harness/Battery”. ALL REPLACEMENT BAT- NO . . . . . . . . Number
TERIES MUST BE PURCHASED LOCALLY.
NPT . . . . . . . National Pipe Thread
Refer to the abbreviations table located on this page OPER . . . . . . Operator
for the various fastener descriptions. Standard POS . . . . . . . Positive
attaching hardware torque values are also provided
PSI . . . . . . . . Pounds per Square Inch
on the inside back cover. If a part requires
lubrication or a nonstandard torque value, it will QTY . . . . . . . Quantity
be specified behind the part number description REF . . . . . . . Reference
in parenthesis. REQ’D . . . . . . Required
Items shown in the parts list that do not have part ROPS . . . . . . Roll Over Protective Structure
numbers are shown for reference purposes only and RPM . . . . . . . Revolutions Per Minute
are NOT available for purchase. RT . . . . . . . . Right
Dimensions are in inches unless otherwise SAE . . . . . . . Society of Automotive Engineers
specified. SN . . . . . . . . Serial Number
SQ . . . . . . . . Square
ST . . . . . . . . Straight
TURBO . . . . . Turbocharger
V . . . . . . . . . Volt
GEHL is a registered trademark of the Gehl Company.

TABLE OF CONTENTS
DESCRIPTION PAGE
SECTION A: MAIN LOADER COMPONENTS

Chassis . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1
Wheel Drives . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3
Engine . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5
Air Cleaner and Muffler . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7
Oil Cooler . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9
Hydrostatic System . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 11
Hydraulics - Chassis . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 13
Hydraulics - Chassis - Main Control Valve . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 21
Hydraulics - Lift Arm . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 25
Auxiliary Hydraulic Controls . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 31
Controls - Lift and Tilt . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 37
Controls - Traction . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 43
Controls - Engine . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 49
Lift Arm and All-Tach™ Attachment System . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 53
ROPS and Seat . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 55
Restraint Bar . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 59
Sound Suppression . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 61
Grille and Engine Cover . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 65
Electrical - Instrument Panel/Harness . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 67
Electrical - Engine Harness/Battery . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 69
Electrical - Lights. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 71
Decals. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 74
SECTION B: HYDRAULIC COMPONENTS

Lift Cylinder . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 83
Tilt Cylinder . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 85
Drive Motor and Parking Brake . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 87
Tandem Pump . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 89
Gear Pump - Standard . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 93
Gear Pump - High-Flow . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 95
Main Control Valve . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 97
Self-Level Valve . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 99
Solenoid Valves - Lift and Tilt . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 101
Solenoid Valve - Brake . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 103
Valve - High-Flow . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 105
(continued on next page)
All-Tach is a trademark of the Gehl Company.

TABLE OF CONTENTS
DESCRIPTION PAGE
SECTION C: ACCESSORIES
Backhoe Mount Kit 807184 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 109
Crossmember Auxiliary Tube Kit 807233 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 109
Backhoe Hydraulics Kit 807193 (4635) and 807231 (4835) . . . . . . . . . . . . . . . . . . . . . 110
All-Tach Kit 807825. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 110
4635 T-Bar and Dual Hand Auxiliary Hydraulics Kit 807239 . . . . . . . . . . . . . . . . . . . . 111
Frame Reinforcement Kit 807238 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 112
Rear Counterweight Kit 807243. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 112
Gehl Quick-Tach™ Kit 807230 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 113
Backhoe 1/2 Mount for 9HD2 Backhoe Kit 806293 . . . . . . . . . . . . . . . . . . . . . . . . . 114
Rearview Mirror Kit 806894 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 114
Backup Alarm Kit 807190. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 115
Cab Heater Kit 807824 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 116
Dome Light Kit 807278 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 117
Horn Kit 806923. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 118
Centrifugal Pre-Cleaner Kit 808204. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 118
Parker Coupler Kit 807050 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 119
Engine Auto Shutdown System Kit 806918. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 119
Strobe Light Kit 805803 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 120
Dual Flasher Kit 806920. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 120
Front Door Kit 807292 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 121
Airboss Solid Segmented Tire Repair Parts . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 122
Self-Level Valve Kit 807336 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 122
Double Gas Spring Kit 807376 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 123
Tilt Cylinder Lock Valve Kit 135564 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 123
Impact Resistant Front Door Kit 807330 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 124
Work Taillight Kit 807293 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 124
Deluxe Interior Kit 807429 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 125
Side-Mounted Cab Heater Kit 807833 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 126
Other Accessories . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 127
Numerical Index . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 128

O-Ring Table, Coupling & Adapter Torque Table . . . . . . . . . . . . . . . . . . . . . . . . . . 135
Torque Specifications Table . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Inside Back Cover
Quick-Tach is a trademark of the Gehl Company.

Spiralock is a trademark of H.D. Holmes, licensed to Detroit Tool Industries.
License includes U.S. and foreign patent rights. Loctite is a registered trademark of the Loctite Corporation.

Chassis . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1
Wheel Drives . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3
Engine . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5
Air Cleaner and Muffler . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7
Oil Cooler . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9
Hydrostatic System . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 11
Hydraulics - Chassis . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 13
Hydraulics - Chassis - Main Control Valve . . . . . . . . . . . . . . . . . . . . 21
Hydraulics - Lift Arm . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 25
Auxiliary Hydraulic Controls . . . . . . . . . . . . . . . . . . . . . . . . . . . 31
Controls - Lift and Tilt . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 37
Controls - Traction . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 43
Controls - Engine . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 49
Lift Arm and All-Tach™ Attachment System . . . . . . . . . . . . . . . . . . . 53
ROPS and Seat . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 55
Restraint Bar . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 59
Sound Suppression . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 61
Grille and Engine Cover . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 65
Electrical - Instrument Panel/Harness . . . . . . . . . . . . . . . . . . . . . . . 67
Electrical - Engine Harness/Battery . . . . . . . . . . . . . . . . . . . . . . . . 69
Electrical - Lights. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 71
Decals. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 74
SL46/4835 SKID LOADERS - CHASSIS
50
51 51
24
2
50
25
Hand & Foot Controls
Hand Controls
15
21
23 20
16 5
22
4
1 3
13
4
9
7
18
17 12
14
10
11
134066x1.cpt
907807/HP1002 1 PRINTED IN USA

SL46/4835 SKID LOADERS - CHASSIS
Ref. Part Quantity Quantity

No. No. Description 4635 4835
1 134201 ASSEMBLY/CHASSIS 1 -
134331 ASSEMBLY/CHASSIS - 1
2 135838 PLATE/CROSSMEMBER 1 1
650495 SCREW/CAP HEX HEAD 1/2 X 1-1/4 6 6
134853 NUT/SPIRALOCK™ 1/2 6 6
3 072343 GASKET/FUEL SENDER (Hi-Tack Gasket Adhesive) 1 1
4 136244 PANEL ASSEMBLY/CHASSIS 2 2
650687 BOLT/CARRIAGE 5/16 X 3/4 4 4
5 134558 COVER ASSEMBLY/RESERVOIR (Oil-resistant RTV) 1 1
651041 SCREW/MACHINE HEX WASHER HEAD 3/8 X 3/4 6 6
6 134756 SIGHT PORT/OIL LEVEL (Loctite® 290) 1 1
7 134299 COVER ASSEMBLY/CHAINCASE (Oil-resistant RTV) 2 2
135270 WASHER/SEALING 3/8 2 2
8 136013 SENSOR/FUEL 1 1
651312 SCREW/MACHINE PHILLIPS HEAD #10 X 1/2 5 5
9 134345 COVER/TOE PLATE 1 1
10 131830 PLATE/FLOOR SHORT 1 1
654030 WASHER/LOCK 1/2 2 2
11 134427 PLATE-FLOOR LONG 1 -
134426 PLATE-FLOOR LONG - 1
654030 WASHER/LOCK 1/2 2 2
12 660080 PLUG/PIPE 3/4 (Pipe Thread Sealant) 2 2
13 131522 PLUG SAE12 2 2
14 135293 BOLT/WHEEL LUG 40 40
15 128591 BREATHER/HYDRAULIC RESERVOIR 1 1
16 127342 CAP/HYDRAULIC RESERVOIR 1 1
17 650494 SCREW/CAP HEX HEAD 1/2 X 1 4 4
654046 WASHER/PLAIN 7/16 4 4
18 132298 SEAL/WASHER 1/2 4 4
20 132050 STRAINER/FUEL FILL 1 1
650702 SCREW/MACHINE PHILLIPS HEAD #6 X 3/8 1 1
21 132051 CAP/FUEL FILL 1 1
22 134824 TRAY ASSEMBLY/BATTERY 1 1
650488 SCREW/CAP HEX HEAD 3/8 X 3/4 3 3
23 135814 LOCK/RUBBER 20-1/2 1 1
24 136201 FILLER/RIGHT CROSSMEMBER 1 1
650486 SCREW/CAP 5/16 X 3/4 1 1
131842 NUT/SPIRALOCK 5/16 1 1
25 136202 FILLER/LEFT CROSSMEMBER 1 1

No. No. Description Dual Hand & T-Bar Hand & Foot
50 134694 COVER/CONTROL 1 -
135247 COVER/CONTROL - 1
51 135006 FLOOR ASSEMBLY/FRONT (4635 Dual Hand & T-Bar Model) 1 -
134536 FLOOR ASSEMBLY/FRONT (4835 Dual Hand & T-Bar Model) 1 -
135090 FLOOR ASSEMBLY/FRONT (4635 H/F Model) - 1
134548 FLOOR ASSEMBLY/FRONT (4835 H/F Model) - 1
PRINTED IN USA 2 907807/HP1002

SL46/4835 SKID LOADERS - WHEEL DRIVES
14
16
3 16
19
4
24 2
3
8
6
9 10
22 11
19 7 12
4 7
5
9 5
8 22 11
13
2 6
10
Right Side Wheel Drive 13 1
12
23 16
15
16 13 11
12
22
1 5
7 2
19
13
10
10 6
6 9
12
3
22 8
11
8
5
7 4 4
Left Side Wheel Drive 2

19
9
134632x.cpt
3 25

SL46/4835 SKID LOADERS - WHEEL DRIVES

1 133966a MOTOR/DRIVE SINGLE SPEED W/ PARKING BRAKE (RTV) 2 2
651085 SCREW/CAP HEX HEAD 1/2 X 1-3/4 (90 ft-lbs) 20 20
129055 NUT/SPIRALOCK™ 1/2 20 20
2 135311 HOUSING/AXLE (Oil-resistant RTV) 4 4
129055 NUT/SPIRALOCK™ 1/2 (90 ft-lbs) 40 40
3 136116 AXLE ASSEMBLY/WHEEL 4 4
079152 NUT/WHEEL 5/8 (180 ft-lbs) 32 32
133957 BOLT/WHEEL 5/8 X 2 32 32
4 131139 SEAL 3 X 4.331 4 4
5 083108 BEARING/CONE (Lithium Grease) 4 4
6 520013 CUP/BEARING 4 4
7 087812 SHIM/BEARING 8 8
8 078946 BEARING/CUP 4 4
9 078945 BEARING/CONE (Lithium Grease) 4 4
10 131663 SPACER/AXLE 4 4
11 134230 ASSEMBLY/SPROCKET #80-40T 4 4
12 135803 WASHER 8 8
13 651381 NUT/HEX SLOTTED 1-1/4 (150 ft-lbs) 4 4
650554 PIN/COTTER 1/4 X 2-1/4 4 4
14 135143 IDLER ASSEMBLY/RIGHT REAR 1 1
079209 NUT/LOCK NYLON INSERT 3/4 (Loctite® 290) 1 1
046588 WASHER/FLAT 25/32 2 2
15 135142 IDLER ASSEMBLY/LEFT REAR 1 1
079209 NUT/LOCK NYLON INSERT 3/4 1 1
046588 WASHER/FLAT 25/32 2 2
16 132027 TUBE/PIVOT INNER 4 4
19 134503 CHAIN/ROLLER #80 X 66 4 2
134827 LINK/CONNECTOR 4 2
134504 CHAIN/ROLLER #80 X 74 - 2
134827 LINK/CONNECTOR - 2
22 131892 SEAL/V-RING (Lithium Grease) 4 4
23 135135 IDLER ASSEMBLY/LEFT FRONT 1 1
046588 WASHER/FLAT 25/32 2 2
24 135136 IDLER ASSEMBLY/RIGHT FRONT 1 1
046588 WASHER/FLAT 25/32 2 2
25 131083 WHEEL/15 X 6 (YELLOW) (7.5 X 15 TIRE) 4 4
122976 WHEEL/16.5 X 9.75 (YELLOW) (12 X 16.5 TIRE) 4 4
079157 WHEEL/16.5 X 9.75 (GRAY) (12 X 16.5 TIRE) 4 4
122978 WHEEL/15 X 13 (YELLOW) (29 X 12.5 X 15 TIRE) 4 4
135465 WHEEL/16.5 X 8.25 (GRAY) (10 X 16.5 TIRE) 4 4
128507 STEM/VALVE 4 4
a) For breakdown see “Section B” of this manual.

SL46/4835 SKID LOADERS - ENGINE
14
1 10
15
16
22
7
11
21 9
12
6 9 11
4
20 18
22
17
13
19 7
8
9
9
3
134069x1.cpt

SL46/4835 SKID LOADERS - ENGINE

No. No. Description 4635/SX 46/4835SXT/DXT
1 134748 ENGINE/DEUTZ F3M1011F 1 -
134749 ENGINE/DEUTZ BF3M1011F - 1
2 139181 BRACKET/MOUNT RIGHT 1 1
651378 SCREW/CAP HEX HEAD M14 X 35MM (108 ft-lbs) (Loctite® 242) 3 3
134966 WASHER/FLAT 1/2 (Loctite® 242) 3 3
3 135407 BRACKET/MOUNT LEFT 1 1
651378 SCREW/CAP HEX HEAD M14 X 35MM (108 ft-lbs) (Loctite® 242) 2 2
134966 WASHER/FLAT 1/2 2 2
4 136063 COUPLING/FLYWHEEL 1 1
656098 SCREW/CAP M8 X 20MM (Loctite® 242) (14 ft-lbs) 6 6
6 136056 HOUSING/FLYWHEEL 1 1
656141 SCREW/CAP SOCKET HEAD M10 X 25MM (28 ft-lbs) 9 9
7 135425 ASSEMBLY/MOUNT 2 2
136601 NUT/HEX 5/8 2 2
8 078919 HOSE/FUEL 1 1
9 062023 CLAMP/HOSE #M5 (Do not Overtighten) 6 6
10 136107 FAN/17" BREEZA 10 BLADE (14 ft-lbs) 1 1
11 133074 FITTING/PIPE 1/4 (Pipe Thread Sealant) 2 2
12 076147 CLAMP/HOSE (Do Not Overtighten) 1 1
656093 SCREW/CAP HEX HEAD M8 X 16MM 1 1
656110 WASHER/LOCK 1 1
13 097076 HOSE/FUEL 1 1
14 138859b STARTER 1 1
133557a STARTER/2.3 kW 1 1
15 132300 ALTERNATOR/ 14 V - 55 AMP 1 1
16 132989 BELT/ALTERNATOR 10MM X 1050MM 1 1
17 132023 FILTER/ENGINE OIL 1 1
18 132024 FILTER/FUEL 1 1
19 135234 BRACKET/FILTER 1 1
656093 SCREW/CAP HEX HEAD M8 X 16MM (14 ft-lbs) 2 2
656110 WASHER/LOCK M8 2 2
650568 SCREW/CAP HEX HEAD 5/16 X 2 (13 ft-lbs) 2 2
20 082339 LOOM/FLEX GUARD 18” (Cut length to fit on replacement) 1 1
21 074091 TIE/NYLON 1 1
22 135427 WASHER/SNUBBER 2 2
a) Engine serial numbers ~ 618097
b) Engine serial numbers 618098 ~
ENGINE IDLE AND HIGH IDLE RPM CHART

TYPE OF ENGINE IDLE (RPM) HIGH IDLE (RPM)
F3M1011F 1300 ± 100 2800 ± 50
BF3M1011F 1300 ± 100 2690 ± 50

SL46/4835 SKID LOADERS - AIR CLEANER & MUFFLER
6
5
2
4
7 10 19
3 12
1
25
12
28
26 27
24
22 21
18 29
12 9 14
23 20
30
17
18
134071x1.cpt

SL46/4835 SKID LOADERS - AIR CLEANER & MUFFLER

1 134491 PIPE/FLEXIBLE EXHAUST 1 -
134685 PIPE/FLEXIBLE EXHAUST - 1
2 134822 MUFFLER 1 -
135086 MUFFLER - 1
3 078931 CLAMP/MUFFLER (Do Not Overtighten) 1 1
4 127428 CLAMP/MUFFLER 2-1/2 (Do Not Overtighten) 1 -
131951 CLAMP/MUFFLER 3” (Do Not Overtighten) - 1
5 134691 PIPE/EXHAUST 1 -
135087 PIPE/EXHAUST - 1
6 078912 BAND/MOUNTING 1 1
7 131706 ISOLATOR 4 4
8 131709 BAR 1 -
132072 BAR/MUFFLER SUPPORT - 1
9 135132 HOSE/INTAKE NA 1 -
135167 HOSE/INTAKE TURBO - 1
10 135131 FILTER ASSEMBLY/AIR CLEANER 1 1
12 087849 CLAMP/HOSE #52 (Do Not Overtighten) 3 3
14 078914 GAUGE/RESTRICTION 1 1
17 134642 PIPE/INTAKE - 1
19 135157 CLAMP/FILTER 1 1
650486 SCREW/CAP HEX HEAD 5/16 X 3/4 2 2
20 135262 HOSE/COUPLING 1/2 - 1
21 135259 TUBE/INTAKE - 1
22 095955 CLAMP/HOSE #10 - 2
23 061166 CLAMP/HOSE #36 - 1
24 135377 SLEEVE/REDUCER 1 1
25 135372 TUBE/AIR CLEANER 1 1
26 135384 HOSE/AIR INTAKE 1 1
27 135261 ASSEMBLY/COVER 1 1
28 135263 EJECTOR/DUST 1 1
29 L99453 ELEMENT/AIR 1 1
30 L99967 FILTER/SAFETY 1 1

SL46/4835 SKID LOADERS - OIL COOLER
16
11
10
5 16
12 1 15
14
9 8
13
5
5
2
17 17
17 3
6
4 7
17
To Engine Port - Fan End
To Engine Port - Flywheel End
134072x.cpt

SL46/4835 SKID LOADERS - OIL COOLER

1 131059 COOLER/STACKED 1 -
131863 COOLER/STACKED - 1
076588 SCREW/FLANGE 3/8 X 3/4 4 4
2 135108 ASSEMBLY/SHROUD 1 -
135119 ASSEMBLY/SHROUD - 1
076588 SCREW/FLANGE 3/8 X 3/4 6 6
3 132270 SEAL/SHROUD 2 -
132271 SEAL/SHROUD - 2
4 135993 SUPPORT/SHROUD 2 2
134966 WASHER/HEAT TREATED 4 4
5 055005 FITTING/90° SAE12 X JIC12 4 4
6 137018 HOSE/MEDIUM PRESSURE 3/4 X 21 1 1
8 132035 SHROUD/LEFT 1 -
132038 SHROUD/LEFT - 1
10 132036 SHROUD/RIGHT 1 -
132039 SHROUD/RIGHT - 1
11 132037 SHROUD/CENTER 1 -
132040 SHROUD/CENTER - 1
13 135182 PAD/COOLER 1 -
135183 PAD/COOLER - 1
14 072587 FITTING/STRAIGHT SAE12 X JIC12 1 1
15 135383 SEAL/SHROUD 19” 1 -
127556 SEAL/SHROUD 22” - 1
16 122348 SEAL/SHROUD 16-5/8” 2 2
17 135385 SEAL/SHROUD 1” 4 4

SL46/4835 SKID LOADERS - HYDROSTATIC
22
38
28
6
7
14
6 18
1
21
2 4 34
4
40
2 26
2
35
39 3
19 14
29 23 8
20
9
14 17 9
14 5 10
13
24 16
9
14
15 12
24 11
36
25
32
37
41
14
27
5
9 33
134073x.cpt

SL46/4835 SKID LOADERS - HYDROSTATIC

1 136387a PUMP/TANDEM 2.48 SERVO 1 1
650453 SCREW/CAP HEX HEAD 1/2 X 1-1/2 (Loctite® 242) (55 ft-lbs) 2 2
134966 WASHER/FLAT 2 2
2 135113 HOSE/VERY HIGH PRESSURE 5/8 X 25-1/2 3 3
3 135114 HOSE/VERY HIGH PRESSURE 5/8 X 26-1/2 1 1
4 131493b FITTING/STRAIGHT SAE12 X FF10 4 4
5 131492b FITTING/STRAIGHT SAE10 X FF10 4 4
6 054816 FITTING/90° SAE08 X JIC08 2 2
7 122641 TUBE/CHARGE 1 1
9 068938 FITTING/90° SAE06 X JIC06 4 4
10 129063a VALVE/SOLENOID 1 1
650706 SCREW/CAP HEX HEAD 1/4 X 2 2 2
135432 WASHER/STAR 1/4 1 1
11 087393 FITTING/TEE 1 1
12 134649 TUBE/BRAKE 1 1
15 135272 TUBE/MOTOR DRAIN RIGHT 1 1
16 134645 TUBE/MOTOR DRAIN LEFT 1 1
17 129301 ORIFICE 5/8 DIAMETER 1 1
19 131571 MANIFOLD 1 1
654006 WASHER/FLAT 3/8 1 1
20 076879 CAP/37° FLARE 3/4 1 1
21 121684 FITTING/90° SAE16 X JIC12 1 1
23 135451 ASSEMBLY/SUPPORT 1 1
656188 SCREW/CAP HEX HEAD M10 (Loctite® 242) (28 ft-lbs) 2 2
24 136467 ASSEMBLY/MOUNT 2 2
136601 NUT/HEX 5/8 1 1
25 135436 MOUNT ASSEMBLY/PUMP 1 -
135440 MOUNT ASSEMBLY/PUMP - 1
26 135448 SUPPORT/PUMP 1 1
134966 WASHER/FLAT HEAT TREATED 2 2
29 132049 TEMPERATURE SWITCH 1 1
32 134647 TUBE/BRAKE RIGHT 1 1
33 134648 TUBE/BRAKE LEFT 1 1
34 076880 FITTING/45° SAE08 X JIC08 1 1
35 135387 SPACER/MANIFOLD 1 1
36 136101 TUBE/INNER MOUNT 1 1
37 135427 WASHER/SNUBBER 1 1
39 080556 CAP/37° FLARE 9/16 1 1
40 128007 CLAMP/TUBE 1 1
41 135773 WASHER/FLAT 5/8 1 1
a) For breakdown see “Section B” of this manual. b) For #10 Face Seal O-Ring, order part number 135124.
PRESSURE SETTINGS AMOUNT OF PRESSURE
CHARGE PRESSURE 250-300 PSI @ Full Throttle (17-21 bar)
TANDEM RELIEF 5500 PSI (379 bar)

SL46/4835 SKID LOADERS - HYDRAULICS - CHASSIS
4635 Model
8 29
9 20
12 18
1
10 41
22
12 9
4 27 9 17
4 11
26 28
30 9
38
39
25
6
9
4 31 11 15
16
37 24 9
4
4 11 9
19 40 35
34 13
10 36 12
4 5
2 12
14 9 18
7 32
134074x.cpt

Ref. Part Quantity

No. No. Description 4635
1 055005 FITTING/90° SAE12 X JIC12 2
2 061574 O-RING 1
4 067761 FITTING/90° SAE10 X JIC10 6
5 072580 FITTING/STRAIGHT SAE10 X JIC10 2
6 075236 CAP/37° 7/8 2
7 079029 FITTING/45° SAE16 X JIC16 1
8 079092 FITTING/TEE SAE12 X JIC12 X JIC12 1
9 079098 PLATE/TWIN COVER 8
650568 SCREW/CAP HEX HEAD 5/16 X 2 (Do Not Overtighten) 5
064260 NUT/LOCK NYLON INSERT 5/16 (Do Not Overtighten) 5
10 079126 CLAMP/TUBE 5/8 (PAIR) 2
11 088904 CLAMP/TUBE 1/2 3
12 135331 STRAP 4
13 135139 FITTING/90° SAE10 X JIC10 1
14 114415 HOSE/SUCTION 1 X 80 1
15 122340 FITTING/TEE JIC08 X SAE08 X JIC08 1
16 122899 FITTING/STRAIGHT SAE10 X SAF08 1
17 127349 FITTING/90° SAE20 X JIC20 1
18 129314a VALVE/SOLENOID 2
650449 SCREW/CAP HEX HEAD 1/4 X 2-1/2 4
134588 NUT/SPIRALOCK™ 1/4 4
135432 WASHER/STAR 1/4 2
19 131577 PLUG SAE10 2
20 131838 FILTER ASSEMBLY/HYDRAULIC 1
651041 SCREW/MACHINE HEX WASHER HEAD 3/8 X 3/4 4
22 134535 TUBE/TILT 1
24 134613 TUBE/TILT 1
25 134614 TUBE/TILT 1
26 134615 TUBE/TILT SOLENOID 1
27 134616 TUBE/TILT 1
28 135297 TUBE/RETURN 1
29 137018 HOSE/MEDIUM PRESSURE 3/4 X 21 1
30 134793 TUBE/LIFT FRONT 1
31 134794 TUBE/LIFT REAR 1
32 134830 TUBE/LIFT 1
34 134878a PUMP/GEAR 1.77 1
650491 SCREW/CAP HEX HEAD 3/8 X 1-1/4 (Loctite® 242) 2
35 134923 TUBE/LIFT 1
36 134980 BRACE 1
38 122778 PLUG 9/16 1
39 089001 CLAMP 1
650490 SCREW/CAP HEX HEAD 3/8 X 1 1
40 072587 STRAIGHT/FITTING SAE12 X JIC12 1
41 074830 FILTER/HYDRAULIC 1

CONTROL VALVE RELIEF 2750±50 PSI @ Full Throttle (190±4 bar)

SX & SXT Models
31
19
1
11 18 1
27 45
8
9 8 16
11 8 10
4 22 43
28 14
4 32
33 15
42 26
25
8
11
10 4
4 18
8 11
8
24 10
41 9 8
9 38
36 37 4
8 35
44 12
8
40 2 5
9
34
5 17
29 9
4
13 8
6
30
134075x.cpt

Ref. Part Quantity

No. No. Description 46/4835SX/SXT
1 055005 FITTING/90° SAE12 X JIC12 2
2 061574 O-RING 1
4 067761 FITTING/90° SAE10 X JIC10 10
6 079029 FITTING/45° SAE16 X JIC16 1
7 079092 FITTING/TEE SAE12 X JIC12 X JIC12 1
9 079126 CLAMP/TUBE 5/8 5
10 088904 CLAMP/TUBE 1/2 3
11 135331 STRAP 4
12 135139 FITTING/90° SAE10 X JIC10 1
13 114415 HOSE/SUCTION 1 X 80 1
15 122899 FITTING/STRAIGHT SAE10 X SAF08 1
16 127349 FITTING/90° SAE20 X JIC20 1
17 135367a VALVE/SELF LEVEL 1
18 129314a VALVE/SOLENOID 2
19 131838 FILTER ASSEMBLY/HYDRAULIC 1
651041 SCREW/MACHINE HEX WASHER HEAD 3/8 X 3/4 4
22 134535 TUBE/TILT 1
24 134613 TUBE/TILT 1
25 134614 TUBE/TILT 1
26 134615 TUBE/TILT SOLENOID 1
27 134616 TUBE/TILT 1
28 135297 TUBE/RETURN 1
29 134621 TUBE/AUXILIARY FRONT 1
30 134622 TUBE/AUXILIARY REAR 1
32 134793 TUBE/LIFT FRONT 1
33 134794 TUBE/LIFT REAR 1
34 134830 TUBE/LIFT 1
35 134831 TUBE/LIFT 1
36 134832 TUBE/TILT 1
37 134833 TUBE/TILT 1
38 134834 TUBE/TILT REAR 1
40 134878a PUMP/GEAR 1.77 1
42 122778 PLUG 9/16 1
43 089001 CLAMP 1
44 072587 STRAIGHT/FITTING SAE12 X JIC12 1
45 074830 FILTER/HYDRAULIC 1


DXT Model
DX Indicator Lamp 7
(Found on Instrument Panel) 21
38
7 67
70 36
39
71 1
49
52 64
71 74 16
69 71 68
18 8 26
63 12
9
51
65 24 31
8
12 11
50 8 73
5 5 30 34
40 8 37
29 41
72
8
11 14
66 28 8
11
5 8 46 15
5
27 9
5
45
71 8 44
20 12
32 8
18
11 12
43 5
6 13
8
2 8
6 9 33
5(46) 19 42
53 17
3(48) 9
35
5 10 47
135027x1.cpt
8
5 5


No. No. Description 4635DXT 4835DXT
1 055005 FITTING/90° SAE12 X JIC12 1 1
2 061574 O-RING 1 1
3 062397 FITTING/45° SAE10 X JIC10 - 1
5 067761 FITTING/90° SAE10 X JIC10 11 10
7 079092 FITTING/TEE SAE12 X JIC12 X JIC12 2 2
8 079098 PLATE/TWIN COVER 12 12
650568 SCREW/CAP HEX HEAD 5/16 X 2 (Do Not Overtighten) 4 4
064260 NUT/LOCK NYLON INSERT 5/16 (Do Not Overtighten) 6 6
9 079126 CLAMP/TUBE 5/8 5 5
10 079288 FITTING/45° SAE20 X JIC20 1 1
11 088904 CLAMP/TUBE 1/2 3 3
12 135331 STRAP 4 4
13 135139 FITTING/90° SAE10 X JIC10 1 1
14 122340 FITTING/TEE JIC08 X SAE08 X JIC08 1 1
15 122899 FITTING/STRAIGHT SAE10 X SAF08 1 1
16 127349 FITTING/90° SAE20 X JIC20 1 1
17 135367a VALVE/SELF LEVEL 1 1
18 129314a VALVE/SOLENOID 2 2
135432 WASHER/STAR 1/4 2 2
19 129706a PUMP/GEAR DOUBLE 1.77/1.02 1 1
650491 SCREW/CAP HEX HEAD 3/8 X 1-1/4 (Loctite® 242) 2 2
21 131838 FILTER ASSEMBLY/HYDRAULIC 1 1
24 134535 TUBE/TILT 1 1
26 134599a VALVE/DX 1 1
27 134613 TUBE/TILT 1 1
28 134614 TUBE/TILT 1 1
29 134615 TUBE/TILT SOLENOID 1 1
30 134616 TUBE/TILT 1 1
31 135297 TUBE/RETURN 1 1
32 134621 TUBE/AUXILIARY FRONT 1 1
33 134622 TUBE/AUXILIARY REAR 1 1
Parts List Continued on Next Page

HIGH FLOW RELIEF 2500±50 PSI @ Full Throttle (172±4 bar)

DXT Model
DX Indicator Lamp 7
(Found on Instrument Panel) 21
38
7 67
70 36
39
71 1
49
52 64
71 74 16
69 71 68
18 8 26
63 12
9
51
65 24 31
8
12 11
50 8 73
5 5 30 34
40 8 37
29 41
72
8
11 14
66 28 8
11
5 8 46 15
5
27 9
5
45
71 8 44
20 12
32 8
18
11 12
43 5
6 13
8
2 8
6 9 33
5(46) 19 42
53 17
3(48) 9
35
5 10 47
135027x1.cpt
8
5 5


(continued from previous page)
34 134643 BRACKET/DX VALVE 1 1
36 134774 TUBE/DX OUTLET 1 1
37 134775 TUBE/DX INLET 1 1
38 134776 TUBE/DX 1 1
39 134777 TUBE/DX 1 1
40 134793 TUBE/LIFT FRONT 1 1
41 134794 TUBE/LIFT REAR 1 1
42 134830 TUBE/LIFT 1 1
43 134831 TUBE/LIFT 1 1
44 134832 TUBE/TILT 1 1
45 134833 TUBE/TILT 1 1
46 134834 TUBE/TILT REAR 1 1
47 134837 HOSE/SUCTION 1-1/4 x 80 1 1
49 134879 CLEVIS/M10 1 1
50 134988 BOX/LEVER PIVOT 1 1
51 135007 SPACER 1 1
52 135009 ROD/CONTROL 1 -
135030 ROD/CONTROL - 1
53 135018 FITTING/TEE SAE10 x JIC12 1 1
63 656048 NUT/HEX M8 1 1
64 656049 NUT/HEX M10 1 1
65 134880 CLEVIS/M8 1 1
66 132213 PLUG/POWER BEYOND 1 1
68 135031 SWITCH/MICRO 1 1
69 134991 LEVER/HAND 1 1
70 135179 LAMP ASSEMBLY/INDICATOR 1 1
72 122778 PLUG 91/6 1 1
73 089001 CLAMP 1 1
74 074830 FILTER/HYDRAULIC 1 1

HIGH FLOW RELIEF 2500±50 PSI @ Full Throttle (172±4 bar)

Main Control Valve - T-Bar and Dual Hand
Mcv-tbdh.cpt


No. No. Description T-Bar Dual Hand
1 650490 SCREW/CAP 3/8 X 1 4 4
2 134852 NUT/SPIRALOCK™ 3/8 4 4
3 132210a VALVE/3-SPOOL 1 -
132692a VALVE/3-SPOOL - 1

Main Control Valve - Hand and Foot
136236x.cpt

Ref. Part Quantity

No. No. Description 46/4835
1 650568 SCREW/CAP 5/16 X 2 2
2 650490 SCREW/CAP 3/8 X 1 4
3 650486 SCREW/CAP 5/16 X 3/4 2
8 136143 ASSEMBLY/BRACKET 1
9 137291 VALVE/PILOT CONTROL 1
10 136072 PLATE/ORIFICE 1
11 136054a VALVE/CONTROL 1
12 134852 NUT/SPIRALOCK™ 3/8 4
13 131842 NUT/SPIRALOCK™ 5/16 2
15 074091 TIE/NYLON 1
16 068938 FITTING/90° SAE06 X JIC06 1
a) For breakdown see “Section B” in this manual.

SL46/4835 SKID LOADERS - HYDRAULICS - LIFT ARM
4635
34 32
37
27
5
26 25
38
7
11
10
13 36
14
13
27 17 14
16
11
13 15
5 38
12
7
13 17 38
10
7
22
7
23 38
23 22 12
24
18 19
21
24
18
134077x.cpt

Ref. Part Quantity

5 079126 CLAMP/TUBE 5/8 (PAIR) 2
650545 SCREW/CAP HEX HEAD 5/16 X 1-1/4 (Do Not Overtighten) 2
650547 SCREW/CAP HEX HEAD 5/16 X 3-1/2 (Do Not Overtighten) 2
10 134368a CYLINDER/LIFT 2
11 134523 PIN/LIFT CYLINDER (Lithium Grease) 2
067847 NUT/LOCK NYLON INSERT 3/8 2
12 134522 PIN/LIFT CYLINDER (Lithium Grease) 2
13 054626 TEE/STRAIGHT SAE08 X JIC08 4
14 134511 TUBE/LIFT CYLINDER 2
15 134513 TUBE/LIFT CYLINDER LEFT 1
16 134512 TUBE/LIFT CYLINDER RIGHT 1
17 087849 CLAMP/HOSE #52 (Do Not Overtighten) 2
18 135058a CYLINDER/TILT 2-1/2 X 17.3 2
19 135306 PIN/TILT CYLINDER (Grease on taper of pin) (80 ft-lbs) 2
134966 WASHER/FLAT 2
21 131689 TUBE/TILT 2
22 088904 CLAMP/TUBE 1/2 2
23 134855 HOSE/MEDIUM PRESSURE 3/8 X 13, W/ PROTECTIVE SLEEVE 2
24 134856 HOSE/MEDIUM PRESSURE 3/8 X 18, W/ PROTECTIVE SLEEVE 2
25 134456 TUBE/TILT INNER 1
26 134455 TUBE/TILT OUTER 1
27 132062 SPACER/TILT TUBE 2
37 131529 PLUG SAE08 1
38 570002 FITTING/GREASE 4

SX & SXT Models
32
31
37 34
27 5
38
26 7 11
33
10
13 5 36
25 14 13
14
17
1 7 11
16
27 15
5
13 38
7 38
12
17
7
10
22 7 13
2
22 5
46 7 38
23 29 8
9 23 12
24 19
18 21
30
18
24
134078x.cpt


No. No. Description 4635SX 46/4835SXT
1 134485 TUBE/AUXILIARY INNER 1 1
2 134483 TUBE/AUXILIARY OUTER 1 1
5 079126 CLAMP/TUBE 5/8 4 4
650545 SCREW/CAP HEX HEAD 5/16 X 1-1/4 (Do Not Overtighten) 2 2
8 134464 TUBE, W/TEE 1 1
9 134474 TUBE, W/TEE 1 1
10 134368a CYLINDER/LIFT 2 2
11 134523 PIN/LIFT CYLINDER (Lithium Grease) 2 2
13 054626 TEE/STRAIGHT SAE08 X JIC08 4 4
14 134511 TUBE/LIFT CYLINDER 2 2
15 134513 TUBE/LIFT CYLINDER LEFT 1 1
16 134512 TUBE/LIFT CYLINDER RIGHT 1 1
18 135058a CYLINDER/TILT 2-1/2 X17.3 2 2
19 135306 PIN/TILT CYLINDER (Grease on taper of pin) (80 ft-lbs) 2 2
21 131689 TUBE/TILT 2 2
22 088904 CLAMP/TUBE 1/2 2 2
23 134855 HOSE/MEDIUM PRESSURE 3/8 X 13 W/ PROTECTIVE SLEEVE 2 2
24 134856 HOSE/MEDIUM PRESSURE 3/8 X 18 W/ PROTECTIVE SLEEVE 2 2
25 134456 TUBE/TILT INNER 1 1
26 134455 TUBE/TILT OUTER 1 1
27 132062 SPACER/TILT TUBE 2 2
29 131952 COUPLER/MALE 1 1
30 131953 COUPLER/FEMALE 1 1
654006 WASHER/FLAT 3/8 1 1
34 134697 HOSE/MEDIUM PRESSURE 3/8 X 21 2 -
134857 HOSE/MEDIUM PRESSURE 3/8 X 19 - 2
37 131529 PLUG SAE08 1 1
38 570002 FITTING/GREASE 4 4
46 075236 CAP/37 FLARE 7/8 2 2

DXT Model
43
37
13
40 32
31
4 34
6
3 5
42 41 38
11 45 33
10
13 36
26 25 14
5 13
16 14
6 17
39 13 7
15 11
5
38 1 38
28 27 12 2
41 13 17
42
10
7
7 5
22 46 12
22
7 38
23 29 8
24 9 23
19
21 30
18
18 24
134079x.cpt


1 134485 TUBE/AUXILIARY INNER 1 1
2 134483 TUBE/AUXILIARY OUTER 1 1
3 134496 TUBE/HI-FLOW INNER 1 1
4 134497 TUBE/HI-FLOW OUTER 1 1
5 079126 CLAMP/TUBE 5/8 4 4
6 079097 CLAMP/TUBE 3/4 2 2
8 134464 TUBE, W/TEE 1 1
9 134474 TUBE, W/TEE 1 1
10 134368a CYLINDER/LIFT 2 2
14 134511 TUBE/LIFT CYLINDER 2 2
15 134513 TUBE/LIFT LEFT CYLINDER 1 1
16 134512 TUBE/LIFT RIGHT CYLINDER 1 1
18 135058a CYLINDER/TILT 2-1/2 X17.3 2 2
19 135306 PIN/TILT CYLINDER (Grease on taper of pin) (80 ft-lbs) 2 2
21 131689 TUBE/TILT 2 2
22 088904 CLAMP/TUBE 1/2 2 2
23 134855 HOSE/MEDIUM PRESSURE 3/8 X 13, W/ PROTECTIVE SLEEVE 2 2
24 134856 HOSE/MEDIUM PRESSURE 3/ 8 X 18, W/ PROTECTIVE SLEEVE 2 2
25 134456 TUBE/TILT INNER 1 1
26 134455 TUBE/TILT OUTER 1 1
654006 WASHER/FLAT 3/8 1 1
38 570002 FITTING/GREASE 4 4
39 131958 COUPLER/MALE FLAT FACE 1 1
40 134509 TUBE/HI-FLOW DRAIN 1 1
41 132148 BAR (Do Not Overtighten) 2 2
654024 WASHER/LOCK 5/16 2 2
650758 BOLT/CARRIAGE 1/4 X 3/4 2 2
070634 NUT/SERRATED LOCK, W/FLANGE 1/4 2 2
46 075236 CAP/37 7/8 2 2

SL46/4835 SKID LOADERS - AUXILIARY HYDRAULIC CONTROLS
T-Bar and Dual Hand Models
12 9
8
11
5
10
1
4
6
2
11
134081x2.cpt

Ref. Part Quantity

No. No. Description T-Bar/Dual Hand
1 135310a SUPPORT ASSEMBLY/PEDAL 1
654004 WASHER/FLAT 5/16 3
2 135309b ASSEMBLY/AUXILIARY PEDAL 1
3 135312c BAR/STOP 1
4 127360 BUSHING/PIVOT 1
B11296 WASHER/FLAT 11/32 1
5 115039 CABLE/CONTROL 1
6 079614 CLAMP/CONDUIT 2
7 065164 END/YOKE 2
650648 NUT/HEX #10 2
8 127488 PIN/CLEVIS 3/16 X 5/8 2
650551 PIN/COTTER 3/32 X 3/4 2
9 088254 LEVER/AUXILIARY VALVE 1
10 087974 JOURNAL/PIVOT 1
11 079213 PIN/SPRING CLEVIS 3/16 2
12 134760 BRACKET/CABLE 1
650486 SCREW/CAP HEX HEAD 5/16 X 3/4 2
a) Serial number 27508 and later on SL4635 models. Earlier serial number models use part number 132165.
Serial number 9514 and later on SL4835 models. Earlier serial number models use part number 132165.
b) Serial number 27508 and later on SL4635 models. Earlier serial number models use part number 132175.
c) Serial number 27508 and later on SL4635 models. Earlier serial number models use part number 132209.

Hand and Foot Models - Electric Auxiliary Control
13
2 12
1
3
10
5
8
7
4
11
134082x2.cpt

Ref Part Electric Aux.

No. No. Description Hand/Foot Qty.
1 132104 ACTUATOR/LINEAR 1
2 131093 KIT/MOUNT 1
074868 SPACER 1
3 127717 CLEVIS/ASSEMBLY 1
074868 SPACER 2
4 136351 BRACKET ASSEMBLY/PIVOT 1
5 135125 LEVER 1
6 127623 PIN/CLEVIS 3/16 1
650551 PIN/COTTER 3/32 X 3/4 1
7 127488 PIN/CLEVIS 3/16 1
650551 PIN/COTTER 3/32 X 3/4 1
8 132075 ERC ASSEMBLY/ELECTRICAL AUXILIARY 1
9 058615 CLAMP/INSULATED 2
10 132149 HOUSING/SWITCH 1
650702 SCREW/SELF-TAPPING PAN HEAD PHILLIPS #6 X 3/8 1
11 132069 HARNESS/MAIN ELECTRICAL AUXILIARY 1
12 132073 HARNESS/PANEL ELECTRICAL AUXILIARY 1
13 131088 SWITCH/ROCKER 1

Hand and Foot Models - Mechanical Auxiliary Control
136252x.cpt

Ref Part Mechanical Aux.

No. No. Description Hand/Foot Qty.
1 071401 NUT/HEX 1/4 2
2 132346 SPACER/PIVOT 1
3 132370 CABLE/54” 1
4 132372 ROD END/FEMALE 1/4 1
5 132373 BEARING/FLANGED 1/2 2
6 132387 KIT/VALVE 1
8 135318 GRIP/RUBBER 2
9 135996 ASSEMBLY/GRIP 1
10 136003 HANDLE/LOWER 1
13 650225 SCREW/SET 5/16 X 1/2 2
14 650484 SCREW/CAP 5/16 X 1/2 2
15 650542 SCREW/CAP 1/4 X 1/2 4
16 650580 WASHER/FLAT 3/16 2
17 650835 SCREW/CAP 1/4 X 1 1
18 650839 SCREW/CAP 1/4 X 2-1/4 1

SL46/4835 SKID LOADERS - CONTROLS - LIFT TILT
T-Bar Model
16
14
15
7
6
5
12
15
2 6
3 9
7
13
3
11
10
11
134083x3.cpt


No. No. Description 4635 T-Bar 4835 T-Bar
1 134889 HANDLE ASSEMBLY/CONTROL 1 1
2 128316 BEARING/BRONZE 2 2
3 056937 WASHER/FLAT 25/32 2 2
4 134327 STOP/T-BAR 1 1
5 054202 JOINT/BALL 1 1
653039 NUT/JAM HEX 3/8 (Loctite® 242) 1 1
6 134792 ROD END/ELASTOMERIC 3/8 2 2
650634 SCREW/CAP HEX HEAD 3/8 X1 2 2
7 650533 SCREW/CAP HEX HEAD 3/8 X 1-1/2 2 2
654004 WASHER/FLAT 5/16 2 2
9 134852 NUT/SPIRALOCK™ 3/8 2 2
10 079039 ROD/END FEMALE 1 1
11 074868 SPACER 2 1
12 135393 PIVOT 1 1
13 135081 ROD/LIFT CONTROL 1 -
134865 ROD/LIFT CONTROL - 1
653039 NUT/JAM HEX 3/8 1 1
14 135082 ROD/TILT CONTROL 1 -
134866 ROD/TILT CONTROL - 1
653039 NUT/JAM HEX 3/8 1 1
15 127488 PIN/CLEVIS 3/16 2 2
650551 PIN/COTTER 3/32 X 3/4 2 2
16 074093 BOOT/CONTROL LEVER 1 1

Hand and Foot Model
136255x.cpt


No. No. Description 4635 Hand/Foot 4835 Hand/Foot
1 653039 NUT/JAM 3/8 2 2
2 651523 NUT/JAM M12 1 1
3 651573 BOLT/CARRIAGE 5/16 X 1 4 4
4 650551 PIN/COTTER 1 1
5 650491 SCREW/CAP 3/8 X 1-1/4 4 4
6 136253 ROD/THROTTLE 1 1
7 136251 CLIP/RETAINING 2 2
8 136190 TAB/THREADED M12 X 1-1/4 1 1
9 136138 PEDAL ASSEMBLY/LEFT 1 1
10 136134 PEDAL ASSEMBLY/RIGHT 1 1
11 135145 CONTROL ROD/LIFT 1 -
135158 CONTROL ROD/LIFT - 1
12 135140 ASSEMBLY/LEVER 1 1
13 135137 ASSEMBLY/PIVOT 1 1
14 134852 NUT/SPIRALOCK™ 3/8 5 5
15 134241 SPACER/PIVOT 1 1
16 132393 BRACKET/BEARING 2 2
17 131842 NUT/SPIRALOCK™ 5/16 4 4
18 128316 BUSHING/PIVOT 6 6
19 127488 PIN/CLEVIS 1 1
20 123383 ROD END 3/8 1 1
21 088912 WASHER/FLAT 1 1
22 079039 ROD END 3 3
23 075288 PIN/ROLL 5/16 X 1-1/4 1 1
24 072866 STUD 1 1
25 056937 WASHER/FLAT 25/32 3 3

Dual Hand Model
131315x.cpt

Ref. Part Quantity

No. No. Description Dual Hand
1 071401 NUT/LOCK 1/4 2
2 132346 PIVOT/SPACER 2
3 132370 CABLE 54 1
4 132371 CABLE 72 1
5 132372 ROD END/FEMALE 1/4 2
6 132373 BEARING/FLANGED 4
7 132387 KIT/CABLE MOUNT 2
8 135318 GRIP/RUBBER 2
11 650225 SCREW/SET SQUARE HEAD 5/16 X 1/2 2
12 650484 SCREW/CAP 5/16 X 1/2 4
13 650580 WASHER/FLAT 3/16 4
14 650835 SCREW/CAP 1/4 X 1 2

SL46/4835 SKID LOADERS - CONTROLS - TRACTION
T-Bar Model
8 7
13
10
8 18 10
15
6
9
18 17
12 19
10 14
10
1 20
11
8 6
21 7
14
4 12
7 8
19
10
8 3
2 9
4
10
7
16
8 10
5
6
134086x2.cpt

Ref. Part Quantity

No. No. Description T-Bar
1 134888 HANDLE ASSEMBLY/CONTROL 1
2 134327 STOP/T-BAR 1
3 135393 PIVOT 1
4 134792 ROD END/ELASTOMERIC 3/8 2
5 134532 ASSEMBLY/PIVOT 1
6 075288 PIN/ROLL 5/16 X 1-1/4 3
7 056937 WASHER/FLAT 25/32 AR
8 128316 BEARING/BRONZE 6
9 134400 BAR/BEARING PIVOT 2
650687 BOLT/CARRIAGE 5/16 X 3/4 4
10 079216 ROD END/FEMALE W/ STUD 8
11 127669 SHAFT/PIVOT 1
12 134658 ASSEMBLY/LEVER 2
13 134659 TUBE ASSEMBLY/PIVOT 1
14 134757 DEVICE/CENTERING 2
656048 NUT/HEX M8 4
15 123722 ROD/TAKEUP 1
653036 NUT/JAM HEX 5/16 (Loctite® 242) 2
16 134436 ROD/9-1/4 2
653036 NUT/JAM HEX 5/16 4
17 134437 ROD/4-3/4 1
653036 NUT/JAM HEX 5/16 2
18 134983 ARM ASSEMBLY/CONTROL 2
19 650491 SCREW/CAP HEX HEAD 3/8 X 1-1/4 1
21 074093 BOOT/CONTROL LEVER 1

Hand and Foot Model
36 3
5 11 20
31 9
8
1 26
20 21 21 15
9 8 23 23 20
3 6 31 5
30 5 20
14 31 33 33
20 35
31
26 13
10 5 16 20 5
31
5 31
18
21 7
29 24
10 22
2 25 1 3
32
8
19 33
29 35
31 11
27 17 12
31 12 8
17 32 27 14
29 16 1
21 20 33
2 25
9
32
21
31 31
17 29
5 32
21 30
17 27
20
134087x2.cpt

Ref. Part Quantity

No. No. Description Hand/Foot
1 056937 WASHER/FLAT 25/32 4
2 074093 BOOT/CONTROL LEFT 2
3 075288 PIN/ROLL 5/16 X 1-1/4 3
5 079216 END/ROD FEMALE 8
8 128316 BEARING/SINTERED BRONZE 4
10 135318 GRIP/RUBBER (Silicone Lubricant) 2
12 134436 ROD 9-1/4 2
13 134437 ROD 4-3/4 1
17 134792 END/ROD ELASTOMERIC 4
18 135604 LEVER/CONTROL RIGHT 1
19 134814 LEVER/CONTROL LEFT 1
20 134851 NUT/SPIRALOCK™ 5/16 8
21 134852 NUT/SPIRALOCK™ 3/8 10
29 650634 SCREW/CAP HEX HEAD 3/8 X 1 4
30 650687 BOLT/CARRIAGE 5/16 X 3/4 4
31 653036 NUT/JAM HEX 5/16 8
32 654004 WASHER/FLAT 5/16 4
33 656048 NUT/HEX M8 X 1-1/4 4
35 654002 WASHER/FLAT 1/4 2
36 135607 ARM/ASSEMBLY 1

Dual Hand Model
22
6
3
8 9
11
8 16
3 15 6 6
10
16 14
6 13 6
6
2 12
18
17 8 3
9
5
21
4
8
4 4 2
13
10
17 9
4 21
6 7
134088x2.cpt

Ref. Part Quantity

No. No. Description Dual Hand
3 075288 PIN/ROLL 5/16 X 1-1/4 3
4 134792 ROD END/ELASTOMERIC 3/8 4
5 134436 ROD/9-1/4 2
6 079216 ROD END/FEMALE W/ STUD 5/16 8
653036 NUT/JAM HEX 5/16 8
650573 BOLT/CARRIAGE 5/16 X 1 4
9 056937 WASHER/FLAT 25/32 4
656048 NUT/HEX M8 4
14 134437 ROD/4-3/4 1
17 074093 BOOT/CONTROL LEVER 2
22 135607 ARM/ASSEMBLY 1

SL46/4835 SKID LOADERS - CONTROLS - ENGINE
T-Bar and Dual Hand Models
17
18
11
2
14
8
13
3 9
8
12
9
6 15
16
10
4
6
7
5
19
134089x2.cpt

Ref. Part Quantity

No. No. Description T-Bar/Dual Hand
1 134914 LEVER ASSEMBLY/THROTTLE 1
2 136475 ROD/CONTROL 1
136251 CLIP/RETAINING 2
3 139108 CLEVIS/HALF 3/8 1
650551 PIN/COTTER 3/32 X 3/4 1
650552 NUT/HEX 3/8 1
4 134243 PEDAL ASSEMBLY/FOOT 1
5 134241 SPACER/PIVOT 1
7 088912 WASHER 1
8 131262 CABLE/THROTTLE 1
9 065164 END/YOKE 2
650648 NUT/HEX #10 2
10 079213 PIN/SPRING CLEVIS 3/16 1
11 127488 PIN/CLEVIS 3/16 1
655001 PIN/COTTER 1/16 X 3/4 1
12 065163 CLAMP 1
650387 SCREW/MACHINE ROUND HEAD #10 X 1/2 2
650648 NUT/HEX #10 2
650549 WASHER/LOCK #10 2
13 131110 LEVER/THROTTLE 1
656149 SCREW/CAP HEX HEAD M6 X 16MM (8 ft-lbs) 2
14 134398 BRACKET/CABLE SUPPORT 1
650490 SCREW/CAP HEX HEAD 3/8 X 1 (23 ft-lbs) 1
15 134447 BRACKET/SPRING 1
16 135772 SPRING 1
17 062282 GRIP 1
18 124078 WASHER 3
19 072866 STUD 1

Hand and Foot Model
1
10
2
7
8
3 5
11
134090x2.plt

Ref. Part Quantity

No. No. Description Hand/Foot
1 136239 HANDLE ASSEMBLY/HAND & FOOT 1
2 114449 ROD END/#10 WITH STUD 1
650648 NUT/HEX MACHINE SCREW #10 2
4 065164 END/YOKE 1
5 127488 PIN/CLEVIS 3/16 1
655001 PIN/COTTER 1/16 X 3/4 1
6 065163 CLAMP 1
650387 SCREW/MACHINE ROUND HEAD #10 X 1/2 2
7 131110 LEVER/THROTTLE 1
656149 SCREW/CAP HEX HEAD M6 X 16 (8 ft-lbs) 2
654022 WASHER/LOCK 1/4 2
9 062282 GRIP 1
10 124078 WASHER 3
11 131262 CABLE/THROTTLE 1

SL46/4835 SKID LOADERS - LIFT ARM & ATTACHMENT SYSTEM
2
11
4
1
11
12
6
7
54
11 10 13 5
53
52 57
64 60 55
51
54 3
53
9
59 52 56
50 60 51
57
13
10 11
59
64
134091x.gif

SL46/4835 SKID LOADERS - LIFT ARM & ATTACHMENT SYSTEM
Quantity
Ref. Part All-Tach™
No. No. Description Attachment
1 133970 ARM/LIFT 1
2 134356 BUSHING (Loctite® 680) 4
3 088101 BUSHING/SPRING 2
4 134523 PIN/LIFT CYLINDER 2
570002 FITTING/GREASE 2
5 131176 ARM/SAFETY (Do Not Overtighten) 1
6 087854 PAD/ARM BRACE 1
7 074860 STEM/RUBBER 1
8 131785 PIN/QUICK RELEASE 1
132289 RIVET/BLIND 1
9 131443 SHIM AR
650490 SCREW/CAP HEX HEAD 3/8 X 1 (Loctite® 242) 4
654026 WASHER/LOCK 3/8 4
10 132088 CAP/GREASE 2
650486 SCREW/CAP HEX HEAD 5/16 X 3/4 (Loctite® 242) 6
12 131201 STEP 1
651168 SCREW/CAP HEX WASHER HEAD SELF-TAPPING 3/8 X 3/4 6
13 134579 PIN (Grease) 2
135773 WASHER/FLAT HEAT TREATED 5/8 2
50 137190 ATTACHMENT/ALL-TACH™ (Lithium Grease) 1
136765a SHIM AR
136766a SHIM AR
51 134219 PIN 2
52 134594 ROD/PUSH 2
53 123554 SPRING/COMPRESSION 2
54 134874 ADAPTER/PUSH ROD 2
137214 WASHER/THRUST 2
651297 SCREW/CAP HEX HEAD 3/8 X 1 (Loctite® 242) 2
55 137212 HANDLE/RIGHT 1
56 137211 HANDLE/LEFT 1
654009 WASHER/THRUST 1/2 2
59 651364 SCREW/CAP SOCKET HEAD 1/2 X 3-1/2 2
60 062756 PIN/SPRING 2
64 135300 PIN 2
a) Add shims 136765 and 136766 as required to achieve a gap between the liftarm and the All-Tach from 0.000” to 0.060” wide.

SL46/4835 SKID LOADERS - ROPS & SEAT
22
44 (Interior - Right
(Interior - Rear of ROPS) 6
Top of ROPS) 43
18
4
20
1
11
10
14 12
2
3 13
2
38
2 15 14
17
9
21
15
37
16
135034x1.cpt
19

No. No. Description 4635 46/4835SX/DX
1 131060 ROPS 1 1
650499 SCREW/CAP HEX HEAD 5/8 x 5-1/2 2 2
654012 WASHER/FLAT 5/8 2 2
2 057557 WASHER/FLAT 17/32 6 6
3 064543 MOUNTING/ISOLATION 2 2
4 131766 WINDOW/ROPS 1 1
5 131767 WEATHERSTRIP/WINDOW 1 1
6 131768 RIP CORD/WEATHERSTRIP 1 1
7 121412 BELT/SEAT 1 1
650495 SCREW/CAP HEX HEAD 1/2 X1-1/4 2 2
654009 WASHER/FLAT 1/2 2 2
8 130085 SEAT 1 1
070648 NUT/FLANGED LOCK 4 4
9 L62459 CASE/OPERATOR’S MANUAL 1 1
650771 BOLT/CARRIAGE 1/4 X 1/2 4 4
10 131805 ASSEMBLY/LIMITER 1 1
11 122828 SLEEVE 1 1
654009 WASHER/FLAT 1/2 2 2
655006 PIN/COTTER 1/8 X 1 1 1
12 077794 SPRING/TORSION 1 1
13 135177 SPRING/GAS 2 2
14 089010 STUD/BALL 4 4
070648 NUT/FLANGED LOCK 4 4
15 089012 CLIP/SPRING 4 4
16 135240 FILLER/ROPS 1 1
17 067750 NUT/SPEED 3 3
651307 SCREW/PHILLIPS ROUND HEAD 1/4 X 1/2 3 3
18 131945 BUSHING 2 2
19 131691 SLIDE/SEAT (SET) 1 1
20 132179 BULKHEAD/HARNESS 1 1
650394 SCREW/MACHINE ROUND HEAD #6 X 1/2 4 4
650658 NUT/HEX #6 4 4
21 129420 PLUG/PLASTIC 3/4 1 1
22 132089 WINDOW/ENCLOSURE 1 1
703692 TAPE/TWO-WAY 6.25 FT. (ATTACH WINDOW TO TOP OF ROPS) 1 1
37 134681 PLUG/PLASTIC 15/32 1 1
38 135252 PLUG/PLASTIC 3/8 2 2
43 058615 CLAMP/INSULATED 2 -
132288 SCREW/CAP HEX WASHER HEAD THREADED 5/16 X 1 2 -
44 076147 CLAMP/HOSE 3 -
651168 SCREW/CAP HEX WASHER HEAD THREADED 3/8 X 3/4 3 -

Deluxe Options
24
23
27
22
31
28 25
8
26
30
33
131362x.cpt

Ref. Part Quantity

No. No. Description Deluxe Options
8 132161 SEAT/SUSPENSION 1
070648 NUT/FLANGED LOCK 4
654046 WASHER/PLAIN 7/16 2
22 132367 ASSEMBLY/TOOLBOX 1
650959 SCREW/CAP HEX WASHER HEAD SELF-TAPPING 1/4 X 1-1/2 2
23 132244 HINGE 1
651307 SCREW/PHILLIPS PAN HEAD 1/4 X 1/2 6
24 132341 COVER/TOOLBOX 1
25 135362 CONSOLE/LEFT 1
067750 NUT/SPEED 6
26 132368 SUPPORT/CONSOLE 1
650294 SCREW/CAP HEX WASHER HEAD SELF-TAPPING 1/4 x 3/8 3
27 132348 CONSOLE/RIGHT 1
067750 NUT/SPEED 6
28 132369 SUPPORT/CONSOLE 1
650294 SCREW/CAP HEX WASHER HEAD SELF-TAPPING 1/4 x 3/8 3
30 135361 FOAM/LEFT ROPS 1
31 132429 FOAM/RIGHT ROPS 1
33 127360 BUSHING/PIVOT 4

SL46/4835 SKID LOADERS - RESTRAINT BAR
131323.png

SL46/4835 SKID LOADERS - RESTRAINT BAR
Ref. Part Quantity

1 056937 WASHER/FLAT 25/32 8
2 067950 RING/EXTERNAL RETAINING 4
3 068034 NUT/LOCK NYLON INSERT 1/2 4
4 078723 SPRING ASSEMBLY/ACTUATOR 2
6 078734 COVER/PIVOT 2
8 121582 BAR/RESTRAINT 1
9 121610 PIVOT/UPPER 2
11 128979 BRACKET ASSEMBLY/RIGHT 2
12 128984 BRACKET ASSEMBLY/LEFT 2
13 650551 PIN/COTTER 3/32 X 3/4 2

SL46/4835 SKID LOADERS - SOUND SUPPRESSION
2
No
3 Washer
used
here.
134096x.cpt

Ref. Part Quantity

1 131769 PAD/SEAT BACK 1
132288 SCREW/CAP HEX WASHER HEAD SELF-TAPPING 5/16 X 1 (Do Not Overtighten) 1
136128 FASTENER/PANEL SNAP-IN 5
2 132078 HEADLINER 1
3 132167 CLIP/HEADLINER 1
4 135374 PAD 1

Deluxe Options
5
12
11
12
12
1
12
10
7
20
6 Remove at perforation to fit

4635 model engine covers
4
8
13 19
16
15 14
134097x1.cpt

Ref. Part Quantity

No. No. Description Deluxe Options
1 132335 PAD/SEATBACK (INSIDE) 1
651363 WASHER/BLACK PLATING 3/8 5
2 132078 HEADLINER 1
3 135573 PAD/CROSSMEMBER LEFT 1
4 135572 PAD/CROSSMEMBER RIGHT 1
5 132167 CLIP/HEADLINER 1
6 135375 PAD/T-BAR COVER 1
7 135394 PAD/LOWER REMOVABLE ROPS 1
070648 NUT/FLANGED LOCK 4
650315 SCREW/CAP HEX WASHER HEAD SELF-TAPPING 1/4 X 1/2 (Do Not Overtighten) 3
8 135363 PAD/FRONT RIGHT 1
9 135464 PAD/FRONT LEFT 1
10 132295 WINDOW/SIDE LEFT 1
11 132296 WINDOW/SIDE RIGHT 1
12 133030 BUSHING 4
13 135366 PAD/RIGHT REAR 1
14 135463 PAD/LEFT REAR 1
15 135374 PAD 1
16 135615 PAD/ENGINE COVER 1
19 135617 PAD/GRILLE TO COOLER 2
20 135649 PAD/FOAM DONUT 1

SL46/4835 SKID LOADERS - GRILLE & ENGINE COVER
19
12
8
13
11 10
11
20
14
17 5
18 16 6
4
2
15
134636x.cpt

SL46/4835 SKID LOADERS - GRILLE & ENGINE COVER

1 131278 ASSEMBLY/GRILLE (Anti-seize compound) 1 1
654009 WASHER/FLAT 1/2 2 2
2 131797 MOUNT/LATCH 1 1
650834 BOLT/CARRIAGE 1/2 X 1-1/2 1 1
650811 BOLT/CARRIAGE 1/2 X 1 1 1
654009 WASHER/FLAT 1/2 2 2
3 131940 BUSHING 1 1
4 131248 LATCH 1 1
5 114665 SPRING/COMPRESSION 1 1
6 131799 ROD ASSEMBLY/LATCH 1 1
7 135365 COVER/ENGINE 1 -
135380 COVER/ENGINE - 1
8 131717 HINGE 2 2
128015 WASHER/FLAT 1-1/32 2 2
9 131913 BUMPER 3 3
653034 NUT/JAM HEX 5/16 3 3
10 132293 SPRING/GAS 1 1
11 122485 STUD/BALL 2 2
654024 WASHER/LOCK 5/16 1 1
12 132306 BRACKET/LOCK 1 1
650573 BOLT/CARRIAGE 5/16 X 1 1 1
654004 WASHER/FLAT 5/16 1 1
13 132366 BRACKET/LOCK 1 1
650573 BOLT/CARRIAGE 5/16 X 1 1 1
14 132493 CLIP/GAS SPRING 2 2
15 091421 PIN/LOCK 1 1
16 123501 WIRE 1 1
17 122633 SLEEVE/CRIMP 2 2
18 076147 CLAMP/HOSE 1 1
19 135381 HOOD/AIR INTAKE 1 1
20 135600 TUBE/FLANGED 1 1
651307 SCREW/MACHINE PHILLIPS PAN HEAD 1/4 X 1/2 3 3
070634 NUT/SERRATED LOCK, W/ FLANGE 1/4 3 3

SL46/4835 SKID LOADERS - ELECTRICAL - INSTRUMENT PANEL
50
135013x.cpt

SL46/4835 SKID LOADERS - ELECTRICAL - INSTRUMENT PANEL
Ref. Part Quantity

No. No. Description 4635 SX/SXT/DXT Options
1 058805 CLAMP/HOSE 1 1 1
2 067750 NUT/CLIP 3 3 3
3 067785 HORN - - 1
4 067888 GROMMET 2 2 2
5 131842 NUT/SPIRALOCK™ 5/16 3 3 4
6 071401 NUT/LOCK 2 2 2
7 072340 HOUR METER 1 1 1
650394 SCREW/MACHINE ROUND HEAD #6 X 1/2 1 1 1
654044 WASHER/LOCK #6 2 2 2
650658 NUT/HEX #6 2 2 2
8 073036 SWITCH/LIGHT - 1 1
9 074091 TIE/NYLON 1 1 1
10 074579 BREAKER/CIRCUIT 2 2 2
11 075104 SWITCH/PUSH BUTTON - - 1
123817 FUSE/15 AMP - - 1
12 076058 RELAY 2 2 2
13 138177 ALARM/SEAT BELT LIGHT 1 1 1
14 088040 HOUSING/DISPLAY 1 1 1
15 089071 CLAMP/HALF 3 3 3
16 089082 CUSHION 4 4 4
17 089083 PLATE/TOP 1 1 1
18 121587 ACTUATOR 1 1 1
19 124089 GROMMET 1 1 1
20 127455 WIRE/HORN - - 1
21 127963 SWITCH/RESTRAINT BAR 1 1 1
22 128738 BULB/LAMP 6 6 6
23 129310 SOCKET/ELECTRIC - - 1
24 130032 PANEL/INSTRUMENTATION 1 1 1
25 130064 GASKET/LAMP HOUSING 1 1 1
26 130342 WIRE ASSEMBLY/POWER 1 1 1
27 131018 HARNESS ASSEMBLY/SEAT SWITCH 1 1 1
28 131050 KEY TAG 1 1 1
29 131159a GAUGE/TEMPERATURE (OIL) 1 1 1
30 131688 SWITCH/IGNITION 1 1 1
131748 KEY/IGNITION SWITCH (SET OF 2) 1 1 1
31 132200a GAUGE/FUEL LEVEL 1 1 1
32 132364 HARNESS/ACCESSORY - - 1
33 134681 PLUG/PLASTIC 15/32 1 - -
34 134977 HARNESS ASSEMBLY/PANEL 1 1 1
35 135008 DECAL/CONTROL PANEL 1 1 1
36 135241 SWITCH/PARK BRAKE 1 1 1
37 650549 WASHER/LOCK #10 4 4 4
38 650550 NUT/HEX MACHINE SCREW #10 4 4 4
39 650573 BOLT/CARRIAGE 5/16 X 1 1 1 1
40 650687 BOLT/CARRIAGE 5/16 X 3/4 2 2 2
41 650848 WASHER/FLAT #6 4 4 4
42 651168 SCREW/CAP SELF-TAPPING 3/8 X 3/4 1 1 1
43 651212 SCREW/MACHINE #5 X 1/2 4 4 4
44 651213 NUT/HEX MACHINE SCREW #5 4 4 4
45 651308 SCREW/PHILLIPS ROUND HEAD 1/4 X 3/4 3 3 3
46 651314 WASHER/STAR #6 4 4 4
47 651343 SCREW/MACHINE ROUND HEAD #10 X 1/2 4 4 4
48 651344 SCREW/MACHINE ROUND HEAD 1/4 X 2-1/2 2 2 2
49 654042 WASHER/STAR 3/8 1 1 1
50 130354 SWITCH/SEAT (FOR USE WITH STANDARD SEAT) 1 1 -
132162 SWITCH/SEAT (FOR USE WITH DELUXE SEAT) - - 1
a) Order replacement bulb - part number 135761.

SL46/4835 SKID LOADERS - ELECTRICAL - ENGINE HARNESS/BATTERY
12
11 (Filter Bracket)
11 (Muffler Mount)
13
9 (ROPS Mount Gusset)
16 (Chaincase End Plate)
To Engine Block
To Engine Block
10 (or optional
(Engine 5 Disconnect
Flywheel - Switch)
Hydraulic
Tubes)
To Chassis
4
10*
11 (Brake Valve Mount) 6

14
10** 7
To Engine Block
Optional
3
22
8
20 21
23
24
2
14
135015x2.cpt

SL46/4835 SKID LOADERS - ELECTRICAL - ENGINE HARNESS/BATTERY
Ref. Part Quantity

1 136234 HARNESS ASSEMBLY/ENGINE 1
650648 NUT/HEX #10 1
656100 NUT/HEX M5 1
055648 TIE/WIRE 1
2 REF BATTERY/12V W/ HANDLE 1
3 122447 ANGLE/BATTERY HOLD DOWN 1
4 075028 CABLE/NEGATIVE BATTERY 1
656105 SCREW/CAP HEX HEAD M8 X 25MM 1
5 054985 CABLE/SOLENOID 1
6 135325 CABLE/POSITIVE BATTERY 1
7 081433 COVER/TERMINAL 1
8 135010 LOOM/BATTERY CABLE 1
9 058805 CLAMP/TUBE 1
651168 SCREW/CAP HEX WASHER HEAD SELF-TAPPING 3/8 X 3/4 1
650426* SCREW/CAP HEX HEAD 1/4 X 1-1/4 1
070634* NUT/HEX 1/4 1
654002* WASHER/FLAT 1/4 1
M12070** SPACER 1
11 076147 CLAMP/HOSE 3
12 131460 SOLENOID/STARTER 1
650758 BOLT/CARRIAGE 1/4 X 3/4 2
13 132063 MODULE/GLOW 1
055648 TIE/WIRE 1
074091 TIE/NYLON 1
14 077685 ROD/BATTERY 2
Ref. Part Quantity

No. No. Description Options
20 091666 SWITCH/DISCONNECT 1
21 129363 BRACKET/SWITCH 1
22 091667 PLATE/FACE 1
23 129385 CABLE/SOLENOID 1
24 129419 BOOT/BATTERY TERMINAL 2

SL46/4835 SKID LOADERS - ELECTRICAL - LIGHTS
7 8
7
8
51
6
9 50
51
9
10
3
11
3
10
11 3
2
10
1
134102x.gif
2

SL46/4835 SKID LOADERS - ELECTRICAL - LIGHTS
Quantity Quantity
Ref. Part 46/4835
No. No. Description 4635 SX/SXT/DXT
1 132046 LAMP/WORK - 2
2 132047 LAMP/TAIL - 2
3 132048 BEZEL - 4
5 131941 HARNESS/REAR GRILLE - 1
6 122011 LIGHT/WORK - 2
7 122847 BRACKET/LIGHT - 2
650687 BOLT/CARRIAGE 5/16 X 3/4 - 2
070648 NUT/FLANGED LOCK - 2
8 073687 GROMMET - 2
9 076147 CLAMP/HOSE (Do Not Overtighten) - 2
064260 NUT/LOCK NYLON INSERT 5/16 - 2
10 132285 CLIP/SINGLE - 4
064260 NUT/LOCK NYLON INSERT 5/16 (Do Not Overtighten) - 4
11 132286 CLIP/DOUBLE - 2
064260 NUT/LOCK NYLON INSERT 5/16 (Do Not Overtighten) - 2
50 135038 PLATE/LIGHT COVER 1 -
51 135039 PLATE/PLATE HOLDER 2 -
650687 BOLT/CARRIAGE 5/16 X 3/4 2 -
064260 NUT/LOCK NYLON INSERT 5/16 2 -
Ref #1 - Order replacement bulb part number 122488.
Ref #2 - Purchase replacement bulb #1156 locally.

SECTION NOTES

SL46/4835 SKID LOADERS - DECALS
GENERAL INFORMATION illustrated reference number. Find the part number,

description and quantity. Refer to the illustration for
replacement locations. Refer to Safety chapter of the
Operator’s Manual for information on the safety
CAUTION decals.
ALWAYS follow safety precautions on decals.
Replace decals if they become damaged or if
the unit is repainted. If repainting, BE SURE NEW DECAL APPLICATION
that all applicable decals are affixed in their Surfaces MUST be free of dirt, dust, grease and
proper locations. foreign material before applying the decal. Remove
smaller portion of decal backing paper and apply the
Decal location information assists in the selection
exposed adhesive to the clean surface, maintaining
and application of new decals, in the event the
proper position and alignment. Peel off remaining
original decals become damaged or the machine is
backing paper and apply hand pressure to smooth out
repainted.
the decal surface.
For decal replacement compare the location
photographs to your machine BEFORE starting to
refinish. Check off each required decal using the
DECAL KITS PAINT FINISH

Language specific decal repaint kits may be Use list below to order paint:
ordered using the following part numbers:
135714 English 906213 One Gallon Yellow
135715 German 906315 One Gallon Red (Optional Color)
135716 French 906317 One Gallon Charcoal Grey
135717 Spanish 906214 6 (12 oz. Spray Cans) Yellow
135718 Italian 906316 6 (12 oz. Spray Cans) Red (Optional Color)
135719 Portuguese 906318 6 (12 oz. Spray Cans) Grey
906323 One Quart Charcoal Grey
Specific decal part numbers for type of model,
control option and the Gehl logo must be
ordered separately from page 76.

Ref. Part Quantity

No. No. Description 4635/SX 46/4835 Turbo Optional
1 137545 REFLECTOR/RED 2 2 2
2 072794 DECAL/HYDRAULIC OIL 1 1 -
3 072797 DECAL/DIESEL FUEL 1 1 -
4 130297 DECAL/HYDRALOC™ 1 1 1
6 073075 DECAL/TURTLE-RABBIT 1 1 1
9 091035 DECAL/DANGER 1 1 -
10 091050 DECAL/DANGER ROTATING COMPONENT 1 1 -
11 093202 DECAL/ELECTRICAL CONTACT 1 1 -
12 L65922 DECAL/OPERATORS MANUAL 1 1 1
13 093367 DECAL/WARNING MANUAL 1 1 -
14 093474 DECAL/WARNING-GENERAL 1 1 -
15 093475 DECAL/WARNING CARRY LOAD LOW 1 1 -
16 093477 DECAL/ROPS LOCK 1 1 -
17 093479 DECAL/LOAD LOW 1 1 -
19 129132 DECAL/LIFT ARM 1 1 -
21 122718 DECAL/WARNING 1 1 -
22 122745 DECAL/WARNING GAS CYLINDERS 1 1 -
24 094951 DECAL/MADE IN USA 1 1 1
28 135184 DECAL/FILTER SELECTION 1 1 1
29 132018 DECAL/SERVICE 1 1 1
30 132139 DECAL/TIE DOWN 4 4 4
33 132166 TAG/RIP CORD 1 1 1
34 121030 STRIP/NON-SKID SURFACE 3 3 3
35 073458 STRIP/NON-SKID SURFACE 1 1 1
37 132294 RING 1 1 1
38 122290 DECAL/GEHL 1 1 1
40 129130 DECAL/CAUTION, DO NOT OPEN 1 1 -
41 129258 DECAL/WARNINGS 1 1 -
42 137660 DECAL/IMPORTANT, ETHER 1 1 -
51 L65928 DECAL/PERSONLIFT 1 1 -
Use the parts lists on page 75 and page 76 to order

decals for your model of Skid Loader. Pages 77-80
show decal locations on the loaders.
Hydraloc is a trademark of the Gehl Company.

4635 Model Designation Decals

Ref. Part Quantity
25 134940 DECAL/4635 2
SX/SXT Model Designation Decals

Ref. Part Quantity
No. No. Description 4635SX 4635SXT 4835SXT
25 134939 DECAL/4635 SX 2 - -
134938 DECAL/4635 SXT - 2 -
134941 DECAL/4835 SXT - - 2
134969 DECAL/4635 SX (OPTIONAL LIGHT GREY) 2 - -
134970 DECAL/4635 SXT (OPTIONAL LIGHT GREY) - 2 -
134972 DECAL/4835 SXT (OPTIONAL LIGHT GREY) - - 2
DXT Model Designation Decals

Ref. Part Quantity
25 134965 DECAL/4635 DXT 2 -
134964 DECAL/4835 DXT - 2
134971 DECAL/4635 DXT (OPTIONAL LIGHT GREY) 2 -
134973 DECAL/4835 DXT (OPTIONAL LIGHT GREY) - 2
Gehl Decals
Ref. Part Quantity
No. No. Description 4635/SX 46/4835 Turbo Optional
18 122616 DECAL/GEHL 2 2 -
122617 DECAL/GEHL (LIGHT GREY) - - 2
20 122432 DECAL/GEHL 1 1 -
122290 DECAL/GEHL (LIGHT GREY) - - 1
36 132016 DECAL/TURBO - 2 -
132187 DECAL/TURBO (LIGHT GREY) - - 2
52 122296 DECAL/GEHL MAX (LIGHT GREY) - - 2
Control Decals
Ref. Part Quantity
No. No. Description T-Bar Hand/Foot Dual Hand
43 134060 DECAL/FORWARD - 2 -
45 123380 DECAL/LIFT - 1 -
46 123381 DECAL/TILT - 1 -
47 072853 DECAL/LIFT TILT 1 - -
48 072854 DECAL/TRACTION 1 - -
49 132395 DECAL/LEFT CONTROL - - 1
50 132396 DECAL/RIGHT CONTROL - - 1

51 17
40
*
9
28 42
29
10
30
* Location of Deutz supplied Engine Service Decal.

Decal does not have a Gehl Part Number.
30 2

34
37
33
35
38
20
1
1
11
48
14
4
47

14
24
12
11
Decal Location on Deluxe Interior Loaders.
13
16
12
43 43
4
49
50
6
45 4
46

15
41
24
13
21
25
18
19
22
36

SECTION NOTES

Lift Cylinder . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 83

Tilt Cylinder . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 85
Drive Motor and Parking Brake . . . . . . . . . . . . . . . . . . . . . . . . . . 87
Tandem Pump . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 89
Gear Pump - Standard . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 93
Gear Pump - High Flow . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 95
Main Control Valve . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 97
Self-Level Valve . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 99
Solenoid Valves - Lift and Tilt . . . . . . . . . . . . . . . . . . . . . . . . . . 101
Solenoid Valve - Brake . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 103
Valve - High-Flow . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 105

SL46/4835 SKID LOADERS - LIFT CYLINDER
1
4
7 9
7
5
7
134368x.cpt

SL46/4835 SKID LOADERS - LIFT CYLINDER
Ref. Part Quantity

134368 CYLINDER /LIFT 1
1 075722 NUT/LOCK 7/8 1
2 134839a TUBE/LIFT CYLINDER 1
3 134840a ROD/LIFT CYLINDER 1
4 134841 PISTON 1
5 134842 GLAND/HEAD 1
6 121554 CAP/GLAND 1
7 134848 KIT/SEAL 1
8 134844 BUSHING/CONNEX 4
9 134843 SPACER 1
a) Includes (2) Ref. #8 - 134844 - Bushing/Connex.

SL46/4835 SKID LOADERS - TILT CYLINDER
8
3
1
2
4
7
8 6
9
134752x3.cpt

SL46/4835 SKID LOADERS - TILT CYLINDER
Ref. Part Quantity

135058 CYLINDER/TILT 1
1 075722 NUT/LOCK 7/8 1
2 134841 PISTON 1
3 135061a TUBE/TILT CYLINDER 1
4 134847 GLAND/HEAD 1
5 121554 CAP/GLAND 1
6 135062b ROD/TILT CYLINDER 1
7 134849 KIT/SEAL 1
8 131488 BUSHING/CONNEX 4
a) Includes (1) Ref. #8 - 131488 - Connex Bushing.
b) Includes (2) Ref. #8 - 131488 - Connex Bushing.

SL46/4835 SKID LOADERS - DRIVE MOTOR & PARKING BRAKE
2 1
1
6
11
8 9 10
3
12 26 23
24
13 16
7 25 15
19
18
17
14
5
4 21 & 22
133966x.cpt

SL46/4835 SKID LOADERS - DRIVE MOTOR & PARKING BRAKE
Ref. Part Quantity

133966 MOTOR/DRIVE WITH PARKING BRAKE 1
1 135336 BLOCK/CYLINDER 1
2 135351 KIT/REPAIR 1
3 135352 CAM 1
4 135353 COVER/VALVING 1
5 135338 KIT/SEAL 1
6 135354 SUPPORT 1
7 135339 BEARING 1
8 135340 BEARING 1
9 135341 SET OF SHIMS 1
10 135342 RING 1
11 135343 RING/SNAP 1
12 135344 SEAL/ENVIRONMENT 1
13 135345 SHAFT 1
14 135355 BRAKE/DISC 1
15 135346 PISTON/BRAKE 1
16 135347 WASHER/SPRING 1
17 135348 RING/SNAP 1
18 135349 SHAFT 1
19 135350 KIT/DISC BRAKE 1
21 135357 KIT/SEAL MOTOR AND BRAKE 1
22 135687 KIT/TOOL MSE02 1
23 132638 PLUG/RUBBER 1
24 138200 O-RING 1
25 138405 O-RING 1
26 138406 PROTECTOR 1

SL46/4835 SKID LOADERS - TANDEM PUMP
Tandem Pump/Gear Pump End
15
30 38
14
26 13 38
34
35
33 17 13
32 39
31 16
4
6
37
3
8
39 20* 24*
39* 28
21*
7 22* 10
23* 25*
28 28
39*
5
19* 28 39
18
9
37
27 3
39
11 2 36 1
3911
29 12
39
Asterisk (*) reference numbers are included

in reference number (18) housing assembly.
131975.tif

Ref. Part
No. No. Description Quantity
136389a PUMP/TANDEM GEAR PUMP END 1
135029b PUMP/TANDEM GEAR PUMP END 1
1 123067 NUT/JAM 1
2 123069 WASHER/SEAL 1
3 123122 SCREW/CAP HEX SOCKET HEAD #12 X 1 8
4 123070 KIT/ROTATING 1
5 136978a PISTON/SERVO 1
128105b PISTON/SERVO 1
6 128106 FOLLOWER/PISTON 1
7 123073 PLATE/COVER 1
8 127989 GASKET 1
10 123080 PLATE/CAM 1
11 060745 BEARING/RACE THRUST 2
12 060746 BEARING/THRUST 1
13 132647 VALVE/RELIEF 5500 PSI 2
16 123123 SCREW/CAP HEX SOCKET HEAD #12 X 1-1/2 6
17 123084 PLATE/VALVE 1
18 136979a ASSEMBLY/HOUSING 1
128112b ASSEMBLY/HOUSING 1
19 055306 BEARING 1
20 136985 PLUG/SAE04 1
21 136980a CRADLE 1
128166b CRADLE 1
22 127679a PIN/DOWEL 2
128130b PIN/DOWEL 2
23 136981a BUSHING/CAM 1
132646b BUSHING/CAM 1
24 136994 SCREW/CAP BUTTON HEAD 2
25 136982a SCREW/CAP 2
136984b SCREW/CAP 2
26 136983a ASSEMBLY/BACKPLATE 1
132653b ASSEMBLY/BACKPLATE 1
27 123129 SHAFT/DRIVE 1
28 131529 PLUG/SAE08 4
29 123094 SPACER 1
30 135445 ADAPTER ASSEMBLY/CHARGE 1
31 132649 ASSEMBLY/CONTROLLER 1
32 127990 KEY 1
33 136986 SEAL/WIPER 1
34 136987 KIT/GEROTOR SEAL 1
35 136995a PLUG/SAE08 1
132650b PLUG/SAE08 1
36 123110 WASHER 1
37 650854 WASHER/FLAT #12 8
38 136988 WASHER 4
39 128108 KIT/SEAL 1
a) SN300317 & later - SL4635; SN400254 & later - SL4835
b) Before SN300317 - SL4635; Before SN400254 - SL4835

Tandem Pump/Engine End
29 38
13
14 39
36 37
33
16 13
31
32 40
30 15
4
35 6
3
8
40 19*
40* 28 23
20
7 10
21
24
22
28 28
40*
5
28
18* 40
17
9
35
26 3
40
11 1
12 2 34
11
40
27
29**
40
Asterisk (*) reference numbers are included
in reference number (17) housing assembly.
Double asterisk (**) reference number is
included in seal kit reference number (40).
131974x.cpt

Ref. Part Quantity

136388a PUMP/TANDEM GEAR ENGINE END 1
134286b PUMP/TANDEM GEAR ENGINE END 1
1 123067 NUT/JAM 1
2 123069 WASHER/SEAL 1
3 123122 SCREW/CAP HEX SOCKET HEAD #12 X 1 8
4 123070 KIT/ROTATING 1
5 136978a PISTON/SERVO 1
128105b PISTON/SERVO 1
6 128106 FOLLOWER/PISTON 1
8 127989 GASKET 1
10 123080 PLATE/CAM 1
11 060745 BEARING/RACE THRUST 2
12 060746 BEARING/THRUST 1
13 132647 VALVE/RELIEF 5500 PSI 2
15 123123 SCREW/CAP HEX SOCKET HEAD #12 X 1-1/2 6
16 123084 PLATE/VALVE 1
17 137017a ASSEMBLY/HOUSING 1
132648b ASSEMBLY/HOUSING 1
18 055306 BEARING 1
19 136985 PLUG/SAE04 1
20 136980a CRADLE 1
128166b CRADLE 1
21 127679a PIN/DOWEL 2
128130b PIN/DOWEL 2
22 136981a BUSHING/CAM 1
132646b BUSHING/CAM 1
23 136994 SCREW/CAP BUTTON HEAD 2
24 136982a SCREW/CAP 2
136984b SCREW/CAP 2
25 137016a ASSEMBLY/BACKPLATE 1
137015b ASSEMBLY/BACKPLATE 1
26 123087 SHAFT/DRIVE 1
27 060748 WASHER 1
28 131529 PLUG/SAE08 4
29 123093 SEAL/SHAFT 1
30 132649 ASSEMBLY/CONTROLLER (Includes #31 and #32) 1
31 127990 KEY 1
32 136986 SEAL/WIPER 1
33 136995a PLUG/SAE08 1
132650b PLUG/SAE08 1
34 123110 WASHER 1
35 650854 WASHER/FLAT #12 8
36 123114 COUPLER 1
37 132248 O-RING 1
38 650433 SCREW/CAP 1/2 X 1-1/4 2
39 654009 WASHER/FLAT 1/2 2
40 128108 KIT/SEAL 1
a) SN300317 & later - SL4635; SN400254 & later - SL4835
b) Before SN300317 - SL4635; Before SN400254 - SL4835

SL46/4835 SKID LOADERS - GEAR PUMP - STANDARD
4635 and SX Models
1
5
4
1
sgearpmp.cpt

SL46/4835 SKID LOADERS - GEAR PUMP - STANDARD
Ref. Part Quantity

No. No. Description 4635/SX/4835SXT
134878 PUMP/GEAR 1.77 SINGLE 1
1 134927 KIT/SEAL 1
2 130034 ASSEMBLY/BACK PLATE 1
3 130033 ASSEMBLY/FRONT PLATE 1
4 134924 ASSEMBLY/BODY 1
5 134926 ASSEMBLY/DRIVE GEAR 1
6 134925 GEAR/IDLER 1
7 603024 SCREW/CAP 8
8 130050 WASHER 4

SL46/4835 SKID LOADERS - GEAR PUMP - HIGH FLOW
DX Models
14
13
12
2
2
2
10
2
2
2
2
9
11
6
4
2
2
2
2
2
3
2
1
5
dblgearp.bmp

SL46/4835 SKID LOADERS - GEAR PUMP - HIGH FLOW
Ref. Part Quantity

No. No. Description 46/4835DXT
129706 PUMP/GEAR 1.77/1.02 DOUBLE 1
1 130034 ASSEMBLY/BACK PLATE 1
2 130059 KIT/SEAL DOUBLE PUMP 1
3 130036 ASSEMBLY/BODY 1.02 1
4 130041 GEAR/SLIP FIT 1.02 1
5 130039 GEAR/IDLER 1.02 1
6 090047 KEY 1
7 130040 PLATE/ADAPTER 20/10 1
8 130046 PLUG/RUBBER 1
9 130035 ASSEMBLY/BODY 1.77 1
10 130037 GEAR/DRIVE 1.77 1
11 130038 GEAR/IDLER 1.77 1
12 130033 ASSEMBLY/FRONT PLATE 1
13 130050 WASHER 4
14 130055 SCREW/CAP 5/16 X 9-1/4 8

SL46/4835 SKID LOADERS - MAIN CONTROL VALVE
2 3
8
7 10
6
11
132210x3.cpt

SL46/4835 SKID LOADERS - MAIN CONTROL VALVE
Ref. Part Quantity

No. No. Description T-Bar Dual Hand Hand/Foot
132692 VALVE/CONTROL - 1 -
132210 VALVE/CONTROL 1 - -
136054 VALVE/CONTROL - - 1
1 132211 VALVE/RELIEF 1 1 1
2 080331 SECTION/INLET 1 1 1
3 132694 SECTION/LIFT 1 1 1
4 132695 SECTION/TILT 1 - -
136318 SECTION/TILT - - 1
133064 SECTION/TILT - 1 -
5 080333 SECTION/AUXILIARY 1 1 1
6 080330 SECTION/OUTLET 1 1 1
7 135371 VALVE/RELIEF 1 1 1
8 135368 POPPET/LOAD CHECK 3 3 3
9 135369 SPRING 3 3 3
10 127629 KIT/DETENT 1 1 1
11 080327 KIT/SEAL 1 1 1

SL46/4835 SKID LOADERS - SELF-LEVEL VALVE
8
10
7
9
10
3
4
11
10
10
10 1
5
6
10
6
10
10
128844x.cpt

SL46/4835 SKID LOADERS - SELF-LEVEL VALVE
Ref. Part Quantity

135367 VALVE/SELF-LEVELING 1
1 080808 PIN 1
2 080809 CAP/ADJUSTMENT 1
3 080810 NUT 1
4 080811 SCREW/SET 1
5 129004 PLUG 1
6 080813 PLUG 2
7 088471 SPRING 2
8 088472 PLUG 2
9 088473 CHECK/LOAD 1
10 129066 KIT/SEAL 1
11 089961 SPRING 1

SL46/4835 SKID LOADERS - SOLENOID VALVE - LIFT/TILT
129314.cpt

SL46/4835 SKID LOADERS - SOLENOID VALVE - LIFT/TILT
Ref. Part Quantity

129314 VALVE/SOLENOID 1
1 138344 VALVE BODY/STEEL 1
2 122840 CARTRIDGE 1
3 129326 COIL 1
4 121897 KIT/SEAL 1

SL46/4835 SKID LOADERS - SOLENOID VALVE - BRAKE
129063.cpt

SL46/4835 SKID LOADERS - SOLENOID VALVE - BRAKE
Ref. Part Quantity

129063 VALVE/SOLENOID 1
1 130167 COIL 1
2 132199 KIT/SEAL 1
3 130166 CARTRIDGE 1
4 REFa BODY 1
a ) Valve body not serviced separately.

SL46/4835 SKID LOADERS - VALVE - HIGH-FLOW
3
5
6
2
134599x1.cpt

SL46/4835 SKID LOADERS - VALVE - HIGH-FLOW
Ref. Part Quantity

134599 VALVE/DX 1
1 135457 ASSEMBLY/DETENT 1
2 135458 BODY/VALVE 1
3 131522 PLUG/SAE12 2
4 135459 VALVE/RELIEF (ADJUST TO 2500 PSI ± 50 AT FULL THROTTLE) 1
5 135460 SPOOL 1
6 135461 ASSEMBLY/FLANGE 1
7 135462 KIT/SEAL (Includes all seals for valve assembly and relief) 1

Backhoe Mount Kit 807184. . . . . . . . . . . . . . . . . . . . . . . . . . . . 109

Crossmember Auxiliary Tube Kit 807233 . . . . . . . . . . . . . . . . . . . . 109
Backhoe Hydraulics Kit 807193 (4635) and 807231 (4835) . . . . . . . . . . . 110
All-Tach Kit 807825 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 110
4635 T-Bar and Dual Hand Auxiliary Hydraulics Kit 807239 . . . . . . . . . . 111
Frame Reinforcement Kit 807238 . . . . . . . . . . . . . . . . . . . . . . . . 112
Rear Counterweight Kit 807243 . . . . . . . . . . . . . . . . . . . . . . . . . 112
Gehl Quick-Tach™ Kit 807230. . . . . . . . . . . . . . . . . . . . . . . . . . 113
Backhoe 1/2 Mount for 9HD2 Backhoe Kit 806293 . . . . . . . . . . . . . . . 114
Rearview Mirror Kit 806894 . . . . . . . . . . . . . . . . . . . . . . . . . . . 114
Backup Alarm Kit 807190 . . . . . . . . . . . . . . . . . . . . . . . . . . . . 115
Cab Heater Kit 807824 (see also Side-Mounted below) . . . . . . . . . . . . . 116
Dome Light Kit 807278 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 117
Horn Kit 806923 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 118
Centrifugal Pre-Cleaner Kit 808204 . . . . . . . . . . . . . . . . . . . . . . . 118
Parker Coupler Kit 807050 . . . . . . . . . . . . . . . . . . . . . . . . . . . . 119
Engine Auto Shutdown System Kit 806918 . . . . . . . . . . . . . . . . . . . 119
Strobe Light Kit 805803 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 120
Dual Flasher Kit 806920 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 120
Front Door Kit 807292 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 121
Airboss Solid Segmented Tire Repair Parts. . . . . . . . . . . . . . . . . . . . 122
Self-Level Valve Kit 807336 (4635) . . . . . . . . . . . . . . . . . . . . . . . 122
Double Gas Spring Kit 807376 . . . . . . . . . . . . . . . . . . . . . . . . . . 123
Tilt Cylinder Lock Valve Kit 135564. . . . . . . . . . . . . . . . . . . . . . . 123
Impact Resistant Front Door Kit 807330 . . . . . . . . . . . . . . . . . . . . . 124
Work Taillight Kit 807293 . . . . . . . . . . . . . . . . . . . . . . . . . . . . 124
Deluxe Interior Kit 807429 . . . . . . . . . . . . . . . . . . . . . . . . . . . . 125
Side-Mounted Cab Heater Kit 807833 . . . . . . . . . . . . . . . . . . . . . . 126
Other Accessories . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 127

SL46/4835 SKID LOADERS - ACCESSORIES
3
6 1
5
7
8 3
Backhoe Mount Kit 807184

7
Ref. Part Qty. Ref. Part Qty.

No. No. Description Req. No. No. Description Req.
REF 807184 KIT/BACKHOE MOUNTING . . . . . . . . . . 1 5 134966 WASHER/FLAT 1/2 . . . . . . . . . . . . . . . . 36
1 071706 NUT/LOCK 1/2 . . . . . . . . . . . . . . . . . . . . 18 6 650503 SCREW/CAP 1/2 X 2-1/2 . . . . . . . . . . . . 8
2 132708 BRACKET/MOUNTING . . . . . . . . . . . . . . 1 7 650569 SCREW/CAP 1/2 X 1-3/4 . . . . . . . . . . . . 8
3 134764 BRACE/END . . . . . . . . . . . . . . . . . . . . . . 2 8 650585 SCREW/CAP 1/2 X 2 . . . . . . . . . . . . . . . 2
4 134765 REINFORCEMENT . . . . . . . . . . . . . . . . . 1
Connect to
Tee under
Lift Arm on
left side.
2
3
4
Crossmember Auxiliary
Tube Kit 807233

REF 807233 KIT/HYDRAULIC DISCONNECT . . . . . . 1 3 131952 COUPLER/MALE . . . . . . . . . . . . . . . . . . . 1
1 134482 TUBE/AUXILIARY OUTER. . . . . . . . . . . 1 4 131953 COUPLER/FEMALE . . . . . . . . . . . . . . . . 1
2 134484 TUBE/AUXILIARY INNER . . . . . . . . . . . 1

Backhoe Hydraulics Kit

807193 (SL4635),
3
Backhoe Hydraulics Kit
807231 (SL4835)
5 8
1
4
Ref. Part. 4635 Qty. Ref. Part. 4835 Qty.

REF 807193 KIT/HYDRAULIC COUPLERS . . . . . . . . 1 REF 807231 KIT/ HYDRAULIC COUPLERS . . . . . . . 1
1 131952 COUPLER/MALE (FLAT-FACED) . . . . 1 1 131952 COUPLER/MALE (FLAT-FACED) . . . . 1
2 131953 COUPLER/FEMALE (FLAT-FACED) . . 1 2 131953 COUPLER/FEMALE (FLAT-FACED) . . 1
3 134798 TUBE/AUXILIARY INNER . . . . . . . . . . . 1 3 134807 TUBE/AUXILIARY HYD. INNER . . . . . . 1
4 134799 TUBE/AUXILIARY OUTER. . . . . . . . . . . 1 4 134808 TUBE/AUXILIARY HYD. OUTER . . . . . 1
5 133077 BRACKET/AUXILIARY TUBE . . . . . . . . 1 5 133077 BRACKET/AUXILIARY TUBE . . . . . . . . 1
650573 BOLT/CARRIAGE 5/16 X 1 . . . . . . . . . 2 650573 BOLT/CARRIAGE 5/16 X 1 . . . . . . . . . 2
131842 NUT/SPIRALOCK 5/16 . . . . . . . . . . . . . 2 131842 NUT/SPIRALOCK 5/16 . . . . . . . . . . . . . 2
8 058610 TEE/SWIVEL JIC10 . . . . . . . . . . . . . . . . 2 8 058610 TEE/SWIVEL JIC10 . . . . . . . . . . . . . . . . 2
All-Tach™ Kit 807825 9
1 12
10
6
8
7 2
5
4 11

REF 807825 KIT/ALL-TACH SL46/4835 . . . . . . . . . . . 1 8 134707 SPRING/COMPRESSION . . . . . . . . . . . 2
1 135160 ALL-TACH BODY . . . . . . . . . . . . . . . . . . 1 068034 NUT/LOCK 1/2” . . . . . . . . . . . . . . . . . . . 2
2 134219 PIN . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2 654009 WASHER/FLAT 1/2” . . . . . . . . . . . . . . . 2
3 134594 ROD/PUSH . . . . . . . . . . . . . . . . . . . . . . . . 2 9 135300 PIN . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2
651542 SCREW/CAP 1/2 X 2-3/4” . . . . . . . . . . 2 650492 SCREW/HEX HEAD 3/8 X 2-1/2” . . . . 2
4 123554 SPRING/COMPRESSION . . . . . . . . . . . 2 067847 NUT/LOCK 3/8” . . . . . . . . . . . . . . . . . . . 2
5 134874 ADAPTER/ROD . . . . . . . . . . . . . . . . . . . . 2 10 651364 SCREW/SOCKET HEAD 1/2 X 4” . . . . . 2
137214 WASHER/FLAT” . . . . . . . . . . . . . . . . . . 2 11 062756 PIN/SPRING. . . . . . . . . . . . . . . . . . . . . . . 2
651297 SCREW/CAP 3/8 X 1” . . . . . . . . . . . . . 2 12 570002 FITTING/GREASE . . . . . . . . . . . . . . . . . . 2
6 136036 HANDLE/RIGHT . . . . . . . . . . . . . . . . . . . 1 13 650846 SCREW/CAP 5/8 X 6”. . . . . . . . . . . . . . . 1
7 136037 HANDLE/LEFT . . . . . . . . . . . . . . . . . . . . . 1

4635 T-Bar/Dual Hand Auxiliary Hydraulics Kit 807239

27
26
Control Valve
16
28
17
17
25
11 8
16
9
23
7 24
5
6
22
1 21
17
5 10
15
6 16
3 2
18
20
4 8 19

REF 807239 KIT/AUXILIARY HYDRAULICS . . . . . . . 1 11 134760 BRACKET/CABLE . . . . . . . . . . . . . . . . . . 1
1 135310 ASSY/PEDAL SUPPORT . . . . . . . . . . . . 1 650486 SCREW/CAP 5/16 X ¾. . . . . . . . . . . . . 2
650487 SCREW/CAP 5/16 X 1 . . . . . . . . . . . . . 3 131842 NUT/SPIRALOCK 5/16 . . . . . . . . . . . . . 2
064260 NUT/LOCK NYLON INSERT 5/16. . . . 3 15 075236 CAP/37 7/8 . . . . . . . . . . . . . . . . . . . . . . . 2
654004 WASHER/FLAT 5/16 . . . . . . . . . . . . . . 3 16 079098 PLATE/TWIN COVER . . . . . . . . . . . . . . . 3
2 135309 ASSY/AUXILIARY PEDAL . . . . . . . . . . . 1 650568 SCREW/CAP 5/16 X 2 . . . . . . . . . . . . . 3
067847 NUT/LOCK NYLON INSERT 3/8 . . . . . 1 654024 WASHER/LOCK 5/16 . . . . . . . . . . . . . . 2
654006 WASHER/FLAT 3/8. . . . . . . . . . . . . . . . 1 064260 NUT/LOCK NYLON INSERT 5/16. . . . 1
3 135312 BAR/STOP . . . . . . . . . . . . . . . . . . . . . . . . 1 654004 WASHER/FLAT 5/16 . . . . . . . . . . . . . . 1
4 127360 BUSHING/PIVOT . . . . . . . . . . . . . . . . . . . 1 17 079126 CLAMP/TUBE 5/8 . . . . . . . . . . . . . . . . . . 3
650692 SCREW/CAP 5/16 X 1-3/4. . . . . . . . . . 1 18 131952 COUPLER/MALE . . . . . . . . . . . . . . . . . . . 1
B11296 WASHER/FLAT 11/32 . . . . . . . . . . . . . 1 19 131953 COUPLER/FEMALE . . . . . . . . . . . . . . . . 1
064260 NUT/LOCK NYLON INSERT 5/16. . . . 1 20 134464 TUBE W/TEE . . . . . . . . . . . . . . . . . . . . . . 1
5 115039 CABLE/CONTROL . . . . . . . . . . . . . . . . . 1 21 134474 TUBE W/TEE . . . . . . . . . . . . . . . . . . . . . . 1
6 079614 CLAMP/CONDUIT . . . . . . . . . . . . . . . . . . 2 22 134483 TUBE/AUXILIARY OUTER. . . . . . . . . . . 1
121002 NUT/LOCK NYLON INSERT . . . . . . . . 4 23 134485 TUBE/AUXILIARY INNER . . . . . . . . . . . 1
7 065164 END/YOKE . . . . . . . . . . . . . . . . . . . . . . . . 2 24 134621 TUBE/AUXILIARY FRONT . . . . . . . . . . . 1
650648 NUT/HEX 10-32. . . . . . . . . . . . . . . . . . . 2 25 134622 TUBE/AUXILIARY REAR . . . . . . . . . . . . 1
8 127488 PIN/CLEVIS .19 . . . . . . . . . . . . . . . . . . . . 4 26 134698 HOSE/MP 5/8 X 48 . . . . . . . . . . . . . . . . . 2
650551 PIN/COTTER 3/32 X 3 . . . . . . . . . . . . . 4 27 074395 CLAMP/HOSE . . . . . . . . . . . . . . . . . . . . . 1
9 088254 LEVER/VALVE AUXILIARY . . . . . . . . . . 1 067847 NUT/LOCK NYLON INSERT 3/8 . . . . . 1
10 087974 JOURNAL/PIVOT . . . . . . . . . . . . . . . . . . 1 654006 WASHER/FLAT 3/8. . . . . . . . . . . . . . . . 1
28 072580 FITTING/STRAIGHT SAE10 JIC10 . . . 2

3
1
4
4
2 2
3
5
1 6
Frame Reinforcement Kit 807238

REF 807238 KIT/BACKHOE MOUNTING . . . . . . . . . . 1 4 134966 WASHER/FLAT 1/2 . . . . . . . . . . . . . . . . 24
1 071706 NUT/LOCK 1/2 . . . . . . . . . . . . . . . . . . . . 12 5 650503 SCREW/CAP 1/2 X 2-1/2 . . . . . . . . . . . . 8
2 134764 BRACE/END . . . . . . . . . . . . . . . . . . . . . . 2 6 650569 SCREW/CAP 1/2 X 1-3/4 . . . . . . . . . . . . 4
3 135094 SPACER . . . . . . . . . . . . . . . . . . . . . . . . . . 2
651380
651353
1
132681
651353
Rear Weight Kit 807243

132681

No. No. Description Req’d No. No. Description Req’d
REF 807243 KIT/REAR WEIGHT. . . . . . . . . . . . . . . . . 1 2 130309 DECAL . . . . . . . . . . . . . . . . . . . . . . . . . . . 2
1 135120 COUNTERWEIGHT . . . . . . . . . . . . . . . . . 1 3 068034 NUT/LOCK NYLON INSERT . . . . . . . . . 2
651380 SCREW/CAP 1 X 6” . . . . . . . . . . . . . . . 2
651353 WASHER/FLAT 1". . . . . . . . . . . . . . . . . 2
132681 NUT/LOCK NYLON INSERT 1-8 . . . . 2

Gehl Quick-Tach™ Kit 807230

7
Ref. Part Qty. Ref. Part. Qty.

REF 807230 KIT/GEHL QUICK-TACH™ . . . . . . . . . . 1 4 065054 PIN/ROLL 1/4 X 2 . . . . . . . . . . . . . . . . . . 2
1 134664 QUICK-TACH ‘35 SERIES . . . . . . . . . . . 1 5 H8049 SPRING . . . . . . . . . . . . . . . . . . . . . . . . . . 2
2 134899 PIN/TILT CYLINDER. . . . . . . . . . . . . . . . 2 6 121707 LINK/PIN LATCH . . . . . . . . . . . . . . . . . . . 2
650833 SCREW/CAP 5/16 X 3 . . . . . . . . . . . . . 2 067847 NUT/LOCK NYLON INSERT 3/8 . . . . . 2
064260 NUT/LOCK NYLON INSERT 5/16. . . . 2 7 128368 HANDLE ASSY/QUICK-TACH . . . . . . . . 1
3 114883 PIN/LATCH . . . . . . . . . . . . . . . . . . . . . . . . 2 650650 SCREW/CAP 1/2 X 3-1/2 . . . . . . . . . . . 1
650503 SCREW/CAP 1/2 X 2-1/2 . . . . . . . . . . . 2 068034 NUT/LOCK NYLON INSERT 1/2 . . . . . 1
068034 NUT/LOCK NYLON INSERT 1/2 . . . . . 2 8 650846 SCREW/CAP 5/8 X 6 . . . . . . . . . . . . . . . 1

2 4
5
1 2 4
6 7
1
Backhoe 1/2 Mount Kit 806293 for
9HD2 Backhoes

REF 806293 KIT/BACKHOE 1/2 MOUNT . . . . . . . . . . 1 4 075208 LATCH. . . . . . . . . . . . . . . . . . . . . . . . . . . . 2
1 061612 PIN 1 X 2-5/8 . . . . . . . . . . . . . . . . . . . . . . 2 650490 SCREW/CAP 3/8 X 1 . . . . . . . . . . . . . . 2
067847 NUT/LOCK 3/8. . . . . . . . . . . . . . . . . . . . 4 650493 SCREW/CAP 3/8 X 2-3/4 . . . . . . . . . . . 2
2 078368 SPRING/TENSION . . . . . . . . . . . . . . . . . 2 5 075211 HANDLE/RIGHT . . . . . . . . . . . . . . . . . . . 1
3 078493 MOUNT/BACKHOE RIGHT . . . . . . . . . . 1 6 078492 MOUNT/BACKHOE LEFT . . . . . . . . . . . 1
650163 SCREW/CAP 3/4 X 1-3/4 . . . . . . . . . . . 3 650163 SCREW/CAP 3/4 X 1-3/4 . . . . . . . . . . . 3
096662 WASHER/FLAT 3/4. . . . . . . . . . . . . . . . 3 096662 WASHER/FLAT 3/4. . . . . . . . . . . . . . . . 3
7 075212 HANDLE/LEFT . . . . . . . . . . . . . . . . . . . . . 1
Rearview Mirror Kit 806894
Ref. Part Qty.

No. No. Description Req.
REF 806894 KIT/REAR VIEW MIRROR . . . . . . . . . . . 1
1 132353 MIRROR . . . . . . . . . . . . . . . . . . . . . . . . . . 1
2 651259 SCREW/CAP THREAD CUTTING
#10 X 7/8 . . . . . . . . . . . . . . . . . . . . . . . . . 2
Approximate
Mirror Location

Backup Alarm Kit 807190
ROPS (REAR VIEW)
2
1
5
4 PLUG FROM MAIN
CHASSIS CROSSMEMBER 3
WIRING HARNESS
8
CONTROL LINKAGE
Ref. Part Qty.

No. No. Description Req’d
REF 807190 KIT/BACKUP ALARM . . . . . . . . . . . . . . . 1
1 135818 BRACKET/ALARM . . . . . . . . . . . . . . . . . 1
071706 NUT/CENTER LOCK 1/2 . . . . . . . . . . . 1
2 135727 ALARM/BACKUP . . . . . . . . . . . . . . . . . . . 1
650758 BOLT/CARRIAGE 1/4X3/4. . . . . . . . . . 2
134588 NUT/FLANGE 1/4 . . . . . . . . . . . . . . . . . 2
3 135722 HARNESS/BACKUP . . . . . . . . . . . . . . . . 1
4 063064 CLIP. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2
5 055648 TIE/WIRE . . . . . . . . . . . . . . . . . . . . . . . . . 5
6 135726 SWITCH/ALARM . . . . . . . . . . . . . . . . . . . 2
650848 WASHER/FLAT #6 . . . . . . . . . . . . . . . . 4
7 134763 BRACKET . . . . . . . . . . . . . . . . . . . . . . . . . 2
650758 BOLT/CARRIAGE 1/4X3/4. . . . . . . . . . 4
134588 NUT/FLANGE 1/4 . . . . . . . . . . . . . . . . . 4
8 132274 HARNESS/POWER TAP . . . . . . . . . . . . 1

49
Cab Heater Kit 807824
10
9
6
48 2
7 5 4
4 4
1 6
3 8
2
1
2
44
37
38 39
35 36
34
47 40
33 45
32
41
30
43 42 31
Ref. Part Qty. Ref. Part. Qty.

REF 807824 KIT/HEATER CAB SL46/4835 . . . . . . . . 1 38 135280 COIL/HEATER . . . . . . . . . . . . . . . . . . . . . 1
1 135379 ADAPTER/90°. . . . . . . . . . . . . . . . . . . . . 2 39 134674 HARNESS/HEATER . . . . . . . . . . . . . . . . 1
2 132503 HOSE/LOW PRESSURE 5/8 X 54 . . . . 2 40 134675 MOTOR . . . . . . . . . . . . . . . . . . . . . . . . . . . 1
3 132504 VALVE/BALL . . . . . . . . . . . . . . . . . . . . . . 1 41 135281 MOUNT/MOTOR . . . . . . . . . . . . . . . . . . . 1
4 095955 CLAMP/HOSE #10 . . . . . . . . . . . . . . . . . 4 42 134677 WHEEL/BLOWER . . . . . . . . . . . . . . . . . . 1
5 058805 CLAMP/HOSE . . . . . . . . . . . . . . . . . . . . . 1 43 134678 RESISTOR/3-SPEED . . . . . . . . . . . . . . . 1
650758 BOLT/CARRIAGE 1/4 X 3/4 . . . . . . . . 1 44 134679 HARNESS/SWITCH . . . . . . . . . . . . . . . . 1
134588 NUT/SPIRALOCK 1/4 . . . . . . . . . . . . . 1 45 135286 BRACKET/TUBE . . . . . . . . . . . . . . . . . . . 1
654002 WASHER/FLAT 1/4. . . . . . . . . . . . . . . . 1 133062 SWITCH/FAN (not shown - ns) . . . . . . 1
6 132362 FITTING/STRAIGHT M18 X 1.5 . . . . . . 2 072854 DECAL/TRACTION (ns) . . . . . . . . . . . . . 1
7 136195 HEATER . . . . . . . . . . . . . . . . . . . . . . . . . . 1 072853 DECAL/LIFT TILT (ns) . . . . . . . . . . . . . . 1
650510 SCREW/THREAD CUT 5/16 X 1/2 . . . 2 134060 DECAL/FORWARD-R (ns) . . . . . . . . . . . 2
8 132148 BAR . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1 123380 DECAL/LIFT (ns) . . . . . . . . . . . . . . . . . . . 1
9 135275 COVER/CONTROL RIGHT . . . . . . . . . . 1 123381 DECAL/TILT (ns) . . . . . . . . . . . . . . . . . . . 1
135376 COVER/CONTROL RIGHT T-BAR . . . . 1 132395 DECAL/LEFT CONTROL (ns) . . . . . . . . 1
10 135283 COVER/CONTROL LEFT . . . . . . . . . . . . 1 132396 DECAL/RIGHT CONTROL (ns) . . . . . . . 1
30 135276 PANEL/FRONT . . . . . . . . . . . . . . . . . . . . 1 130297 DECAL/HYDRALOC™ (ns) . . . . . . . . . . 1
31 135282 PANEL/END . . . . . . . . . . . . . . . . . . . . . . . 1 47 135382 MAT/FLOOR. . . . . . . . . . . . . . . . . . . . . . . 1
32 135277 BLOCK/AIR . . . . . . . . . . . . . . . . . . . . . . . 1 48 135399 SEAL/SHROUD . . . . . . . . . . . . . . . . . . . . 2
33 135278 ASSEMBLY/BODY . . . . . . . . . . . . . . . . . 1 49 135378 SEAL/COVER . . . . . . . . . . . . . . . . . . . . . 2
34 135279 BRACKET/LOUVRE MOUNT. . . . . . . . . 1 135774 HALF CLAMP/HOSE (ns). . . . . . . . . . . . 2
35 134670 LOUVRE . . . . . . . . . . . . . . . . . . . . . . . . . . 1 650771 BOLT/CARRIAGE 1/4 X 1/2 (ns) . . . . . 2
36 134671 ASSEMBLY/COVER . . . . . . . . . . . . . . . . 1 134588 NUT/SPIRALOCK™ 1/4 (ns) . . . . . . . . . 2
37 134672 MAGNET . . . . . . . . . . . . . . . . . . . . . . . . . . 2 055648 TIE/WIRE (ns) . . . . . . . . . . . . . . . . . . . . . 4

nd
ou
Dome Light Kit 807278 Gr
to
ire 2
ckW
Bla
132145 Left ROPS Panel
Ref. Part Qty.

No. No. Description Req.
REF 807278 KIT/DOME LIGHT . . . . . . . . . . . . . . . . . . 1
1 073686 GROMMET . . . . . . . . . . . . . . . . . . . . . . . . 2
2 135044 HARNESS/DOME . . . . . . . . . . . . . . . . . . 1
3 135045 LIGHT/DOME . . . . . . . . . . . . . . . . . . . . . . 1
4 135109 SCREW/SELF TAPPING #6 X 1/2 . . . . 2

Horn Kit 806923
3
1
4

REF 806923 KIT/HORN. . . . . . . . . . . . . . . . . . . . . . . . . 1 3 127455 WIRE/HORN. . . . . . . . . . . . . . . . . . . . . . . 1
1 075104 SWITCH/PUSH BUTTON . . . . . . . . . . . . 1 4 132334 WIRE/HORN . . . . . . . . . . . . . . . . . . . . . . 1
2 067785 HORN . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1
070648 NUT/HEX FLANGE 5/16 . . . . . . . . . . . 1
Centrifugal Pre-Cleaner Kit 808204
135335
Remove

Parker Coupler Kit 807050

4
5
7
1
10
2
9
Ref. Part Qty.
Engine Auto Shutdown
No. No. Description Req. System Kit 806918
REF 807050 KIT/PARKER COUPLER . . . . . . . . . . . . 1
1 048953 O-RING #12 . . . . . . . . . . . . . . . . . . . . . . . 2
132537
2 055896 O-RING #8 . . . . . . . . . . . . . . . . . . . . . . . . 1
3 056104 CAP/DUST . . . . . . . . . . . . . . . . . . . . . . . . 1
4 079417 CAP/DUST . . . . . . . . . . . . . . . . . . . . . . . . 1
5 079418 PLUG/DUST . . . . . . . . . . . . . . . . . . . . . . . 1
6 122864 COUPLER/MALE SAE12 . . . . . . . . . . . . 1
7 122865 COUPLER/FEMALE . . . . . . . . . . . . . . . . 1
8 128031 COUPLER/MALE . . . . . . . . . . . . . . . . . . . 1
9 133096 FITTING/STRAIGHT BULKHEAD . . . . . 1
10 133098 FITTING/STRAIGHT BULKHEAD . . . . . 2
Main Harness
To Fuel Shutoff Solenoid

located at back of Engine
on left side near Battery.

Strobe Light Kit 805803

1
3
4
10
9
8
6
2 12
11
Ref. Part Qty.

Ref. Part. Qty.
REF 805803 KIT/STROBE LIGHT . . . . . . . . . . . . . . . . 1
7 078151 CONNECTOR/TAP . . . . . . . . . . . . . . . . . 1
1 088296 STROBE . . . . . . . . . . . . . . . . . . . . . . . . . . 1
8 055919 CLIP/WIRE . . . . . . . . . . . . . . . . . . . . . . . . 3
2 088297 TERMINAL/RING . . . . . . . . . . . . . . . . . . . 1
9 122483 HARNESS/STROBE . . . . . . . . . . . . . . . . 1
3 073687 GROMMET . . . . . . . . . . . . . . . . . . . . . . . -1
10 132274 HARNESS/POWER TAP . . . . . . . . . . . . 1
4 071105 CONNECTOR/LINE. . . . . . . . . . . . . . . . . 1
11 138310 TERMINAL/INS FEMALE 1/4. . . . . . . . . 1
5 078150 WIRE/BEACON . . . . . . . . . . . . . . . . . . . . 1
12 138313 TERMINAL/INS MALE 1/4 . . . . . . . . . . . 1
6 073200 TERMINAL/MALE BULLET . . . . . . . . . . 1
5
7
Dual Flasher Kit 806920 1
14
15 13

REF 806920 KIT/DUAL FLASHER. . . . . . . . . . . . . . . . 1 10 055925 FLASHER (not shown) . . . . . . . . . . . . . . 1
1 058615 CLAMP/INSULATED . . . . . . . . . . . . . . . . 2 11 089543 MOUNT/BRACKET FLASHER
2 064145 SPACER . . . . . . . . . . . . . . . . . . . . . . . . . . 2 (not shown) . . . . . . . . . . . . . . . . . . . . . . . 1
3 075217 BRACKET/FLASHER RIGHT. . . . . . . . . 1 651360 SCREW/MACHINE #6 X 1/4 . . . . . . . . 1
4 075218 BRACKET/FLASHER LEFT 654044 WASHER/LOCK #6 . . . . . . . . . . . . . . . . 1
(not shown) . . . . . . . . . . . . . . . . . . . . . . . 1 650658 NUT/HEX #6 . . . . . . . . . . . . . . . . . . . . . 1
5 075219 GUARD/FLASHER RIGHT . . . . . . . . . . . 1 12 055648 TIES/WIRE (not shown) . . . . . . . . . . . . 24
6 075220 GUARD/FLASHER LEFT (not shown) . 1 13 650577 SCREW/CAP 5/16 X 1-1/2 . . . . . . . . . . . 4
7 087234a LIGHT/WARNING ASSY . . . . . . . . . . . . 2 14 653007 NUT/HEX 5/16 . . . . . . . . . . . . . . . . . . . . . 4
8 133069 WIRE/FLASHER MAIN (not shown) . . . 1 15 654024 WASHER/LOCK 5/16 . . . . . . . . . . . . . . . 4
9 133070 WIRE/FLASHER DUAL. . . . . . . . . . . . . . 1 a) For replacement Lens order 087247. For replacement
Bulb local purchase #1166 or equivalent.

18
4
2 12
23
1
6 5
11
9 10
24
22 819
7
20 14
21 13
13
3
15
1
25
16 26
27
Front Door Kit 807292
17
17
REF 807292 KIT/FRONT DOOR 46/48/56/6635 . . . . 1 13 135455 SEAL/BULB . . . . . . . . . . . . . . . . . . . . . . . 2
1 132713 ASSY/HINGE . . . . . . . . . . . . . . . . . . . . . . 2 14 135456 STRIP/TRIM . . . . . . . . . . . . . . . . . . . . . . . 1
650487 SCREW/CAP 5/16 X 1.00 . . . . . . . . . . 4 15 095281 FOAM/EXTENSION. . . . . . . . . . . . . . . . . 2
654004 WASHER/FLAT 5/16 . . . . . . . . . . . . . . 4 16 135446 PLATE/FILLER. . . . . . . . . . . . . . . . . . . . . 1
064260 NUT/LOCK 5/16 . . . . . . . . . . . . . . . . . . 4 650811 BOLT/CARRIAGE ½ X 1.00 . . . . . . . 14
2 135437 ASSY/DOOR . . . . . . . . . . . . . . . . . . . . . . 1 653018 NUT/HEX ½ . . . . . . . . . . . . . . . . . . . . 14
3 135454 SEAL/BULB . . . . . . . . . . . . . . . . . . . . . . . 1 654009 WASHER/FLAT ½ . . . . . . . . . . . . . . . . 14
4 135453 SEAL/BULB . . . . . . . . . . . . . . . . . . . . . . . 1 17 129543 FOAM/SEAL . . . . . . . . . . . . . . . . . . . . . . . 3
5 132682 GLASS/DOOR . . . . . . . . . . . . . . . . . . . . . 1 18 113839 SEAL/BULB . . . . . . . . . . . . . . . . . . . . . . . 1
6 132715 WEATHERSTRIP/WINDOW . . . . . . . . . 1 19 078200 MOTOR/DOOR WIPER . . . . . . . . . . . . . 1
7 078168 HANDLE/DOOR LATCH . . . . . . . . . . . . . 1 650815 SCREW/MACHINE #10 X 3/4 . . . . . . . 1
650815 SCREW/MACHINE . . . . . . . . . . . . . . . . 2 650584 WASHER/FLAT #10 . . . . . . . . . . . . . . . 6
650584 WASHER/FLAT #10 . . . . . . . . . . . . . . . 2 650549 WASHER/LOCK #10. . . . . . . . . . . . . . . 1
650549 WASHER/LOCK #10. . . . . . . . . . . . . . . 2 650550 NUT/HEX . . . . . . . . . . . . . . . . . . . . . . . . 1
650550 NUT/HEX MACHINE #10 . . . . . . . . . . 2 20 078248 ARM/ADJUSTABLE. . . . . . . . . . . . . . . . . 1
8 095263 COVER/PLATE . . . . . . . . . . . . . . . . . . . . 1 21 078249 BLADE. . . . . . . . . . . . . . . . . . . . . . . . . . . . 1
9 078170 BRACKET/LATCH . . . . . . . . . . . . . . . . . . 1 22 114263 WASHER . . . . . . . . . . . . . . . . . . . . . . . . . 2
650448 SCREW/CAP1/4 X 3/4 . . . . . . . . . . . . . 2 23 055919 CLIP/WIRE . . . . . . . . . . . . . . . . . . . . . . . . 3
071401 NUT/LOCK 1/4 . . . . . . . . . . . . . . . . . . . 2 24 132736 WIRE/WIPER . . . . . . . . . . . . . . . . . . . . . . 1
10 078171 LOCK/CAB . . . . . . . . . . . . . . . . . . . . . . . . 1 25 135575 FILLER/DOOR . . . . . . . . . . . . . . . . . . . . . 1
650548 SCREW/MACHINE 10 X ½ . . . . . . . . . 4 650811 BOLT/CARRIAGE ½ X 1.00 . . . . . . . . 4
650549 WASHER/LOCK #10. . . . . . . . . . . . . . . 4 653018 NUT/HEX ½ . . . . . . . . . . . . . . . . . . . . . 4
650550 NUT/HEX MACHINE #10 . . . . . . . . . . 4 654009 WASHER/FLAT ½ . . . . . . . . . . . . . . . . . 8
11 136214 PLATE/LOCK . . . . . . . . . . . . . . . . . . . . . . 1 26 075308 STRIP/BOLT . . . . . . . . . . . . . . . . . . . . . . 1
650663 SCREW/CAP 1/4 X 5/8 . . . . . . . . . . . . 2 650448 SCREW/CAP 1/4 X 3/4 . . . . . . . . . . . . 5
654002 WASHER/FLAT 1/4. . . . . . . . . . . . . . . . 4 071401 NUT/LOCK 1/4. . . . . . . . . . . . . . . . . . . . 5
071401 NUT/LOCK 1/4 . . . . . . . . . . . . . . . . . . . 2 27 080072 FLAP/RUBBER . . . . . . . . . . . . . . . . . . . . 1
12 135435 FRAME/DOOR . . . . . . . . . . . . . . . . . . . . . 1
650510 SCREW/CAP THREAD CUT 5/16 . . . 6

Airboss Solid Segmented Tire Repair Parts

(To repair tire assemblies: 807425, 807426, 807387, and 807388)
Ref. Part Qty. Ref. Part. Qty.No.

No. No. Description Req’d No. Description Req’d
807425 TIRE ASSEMBLY/RIGHT 807387 TIRE ASSEMBLY/RIGHT
807426 TIRE ASSEMBLY/LEFT 807388 TIRE ASSEMBLY/LEFT
REPAIR PARTS: REPAIR PARTS:
1 135709 SEGMENT/TIRE . . . . . . . . . . . . . . . . . . . 1 1 135658 SEGMENT/ALTRAKKA III . . . . . . . . . . . 1
129039 SCREW/HEX HEAD M10 X 30MM . . . 1 129038 SCREW/HEX HEAD M8 X 26MM . . . . 1
071246 NUT/NYLON M10-1.5 . . . . . . . . . . . . . . 1 071245 NUT/NYLON M8 . . . . . . . . . . . . . . . . . . 1
656113 WASHER/FLAT M10. . . . . . . . . . . . . . . 1 656111 WASHER/FLAT M8 . . . . . . . . . . . . . . . . 1
Self-Level Valve Kit 807336
10
7
5
8
9 1
6
4
2
3
1
REF 807336 KIT/SELF-LEVEL VALVE . . . . . . . . . . . . 1 6 134831 TUBE/LIFT . . . . . . . . . . . . . . . . . . . . . . . . 1
1 067761 CONNECTOR/90° . . . . . . . . . . . . . . . . . . 4 7 134832 TUBE/TILT . . . . . . . . . . . . . . . . . . . . . . . . 1
2 135367 VALVE/SELF-LEVEL . . . . . . . . . . . . . . . 1 8 134833 TUBE/TILT REAR . . . . . . . . . . . . . . . . . . 1
3 650733 SCREW/CAP . . . . . . . . . . . . . . . . . . . . . . 2 9 079126 CLAMP/TUBE 0.625” . . . . . . . . . . . . . . . 1
4 131842 NUT/SPIRALOCK . . . . . . . . . . . . . . . . . . 2 10 650784 SCREW/CAP . . . . . . . . . . . . . . . . . . . . . . 1
5 134834 TUBE/SELF-LEVEL. . . . . . . . . . . . . . . . . 1

Double Gas Spring Kit 807376
2 8
4
5
7
3 3
1 1
3
3
8
7
9
Ref Part Qty. Ref Part Qty.

REF 807376 KIT/DOUBLE GAS SPRING. . . . . . . . . . 1 5 650448 SCREW/CAP 1/4 X 3/4. . . . . . . . . . . . . . 2
1 135178 SPRING/GAS . . . . . . . . . . . . . . . . . . . . . . 2 6 134588 NUT/SPIRALOCK 1/4 . . . . . . . . . . . . . . . 2
2 135661 SPACER . . . . . . . . . . . . . . . . . . . . . . . . . . 2 7 650725 SCREW/CAP 5/16 X 2-1/4 . . . . . . . . . . . 2
3 135620 END/ROD . . . . . . . . . . . . . . . . . . . . . . . . . 4 8 064260 NUT/LOCK 5/16 . . . . . . . . . . . . . . . . . . . . 2
4 135186 BRACKET . . . . . . . . . . . . . . . . . . . . . . . . . 1 9 123672 SPACER . . . . . . . . . . . . . . . . . . . . . . . . . . 2
3 Tilt Cylinder Lock Valve Kit 135564

REF 135564 KIT/TILT LOCK VALVE . . . . . . . . . . . . . 1 3 135590 HOSE 1/2 X 42 . . . . . . . . . . . . . . . . . . . . 2
1 112712 CONNECTOR/STRAIGHT . . . . . . . . . . . 4
2 135577 VALVE/LOCK . . . . . . . . . . . . . . . . . . . . . . 1

Impact Resistant Front Door Kit 807330 1
5 4
7
6 2
6
5
8

REF 807330 KIT/IMPACT RESISTANT DOOR . . . . . 1 650487 SCREW/CAP 5/16 X 1 . . . . . . . . . . . . . 4
1 135435 FRAME/DOOR . . . . . . . . . . . . . . . . . . . . . 1 064260 NUT/LOCK 5/16 . . . . . . . . . . . . . . . . . . 4
650510 SCREW/CAP THREAD CUT 5/16 . . . 6 654004 WASHER/FLAT 5/16 . . . . . . . . . . . . . . 4
2 135456 STRIP/TRIM . . . . . . . . . . . . . . . . . . . . . . . 1 6 130341 HANDLE/DOOR . . . . . . . . . . . . . . . . . . . . 2
3 132214 DOOR/POLYCARBONATE . . . . . . . . . . 1 7 067040 MAGNET . . . . . . . . . . . . . . . . . . . . . . . . . . 1
4 133933 ASSEMBLY/HINGE . . . . . . . . . . . . . . . . . 1 651084 SCREW/MACHINE ROUND HEAD . . 2
650835 SCREW/CAP 1/4 X 1 . . . . . . . . . . . . . . 4 650550 NUT/HEX #10 X 1 . . . . . . . . . . . . . . . . . 2
654002 WASHER/FLAT 1/4. . . . . . . . . . . . . . . . 4 8 135575 FILLER/DOOR . . . . . . . . . . . . . . . . . . . . . 1
071401 NUT/LOCK 1/4. . . . . . . . . . . . . . . . . . . . 4 650811 BOLT/CARRIAGE 1/2 X 1 . . . . . . . . . . 4
5 132713 ASSEMBLY/HINGE . . . . . . . . . . . . . . . . . 2 654009 WASHER/FLAT . . . . . . . . . . . . . . . . . . . 8
653018 NUT/HEX 1/2 . . . . . . . . . . . . . . . . . . . . . 4
Work Taillight Kit 807293 3

2
2 Panel Harness
1 3
4
4
5
Engine 6 8
Harness 7 8
6
11 8
Instrument Panel 7 8
9 6
10
10
9
REF 807293 KIT/WORK TAILLIGHT . . . . . . . . . . . . . . 1 6 132285 CLIP/SINGLE . . . . . . . . . . . . . . . . . . . . . . 4
1 122011 LIGHT/WORK. . . . . . . . . . . . . . . . . . . . . . 2 064260 NUT/LOCK 5/16 . . . . . . . . . . . . . . . . . . 4
2 122847 BRACKET/LIGHT . . . . . . . . . . . . . . . . . . 2 7 132286 CLIP/DOUBLE . . . . . . . . . . . . . . . . . . . . . 2
650687 BOLT/CARRIAGE 5/16 X 3/4 . . . . . . . 2 064260 NUT/LOCK 5/16 . . . . . . . . . . . . . . . . . . 2
070648 NUT/FLANGED LOCK . . . . . . . . . . . . . 2 8 132048 BEZEL . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4
3 073687 GROMMET . . . . . . . . . . . . . . . . . . . . . . . . 2 9 132047 LAMP/TAIL . . . . . . . . . . . . . . . . . . . . . . . . 2
4 076147 CLAMP/HOSE . . . . . . . . . . . . . . . . . . . . . 2 10 132046 LAMP/WORK . . . . . . . . . . . . . . . . . . . . . . 2
064260 NUT/LOCK 5/16 . . . . . . . . . . . . . . . . . . 2 11 073036 SWITCH/LIGHT . . . . . . . . . . . . . . . . . . . . 1
5 131941 HARNESS/REAR GRILLE . . . . . . . . . . . 1

Deluxe Interior Kit 807429 13
1 14
12
No washer used here
17
18
20
15
19
2 16
3
21
9
8
4 11
6 10
7
5

No. No. Description Req. No. No. Description Req
REF 807430 KIT/DELUXE INTERIOR 46/4835 . . . . . 1 14 132341 COVER/TOOLBOX . . . . . . . . . . . . . . . . . 1
1 132335 PAD/SEATBACK . . . . . . . . . . . . . . . . . . . 1 651307 SCREW/PHILLIPS RH 1/4X1/2 . . . . . . 3
132288 SCREW/THREADED 5/16X1.00 . . . . . 6 071401 NUT/LOCK 1/4. . . . . . . . . . . . . . . . . . . . 3
651363 WASHER/FLAT 3/8 (BLACK) . . . . . . . 5 15 135362 CONSOLE/LEFT . . . . . . . . . . . . . . . . . . . 1
2 135375 PAD/T-BAR COVER . . . . . . . . . . . . . . . . 1 067750 NUT/SPEED . . . . . . . . . . . . . . . . . . . . . . 6
3 135394 PAD/LOWER REMOVABLE ROPS . . . . 1 651308 SCREW/PHILLIPS RH 1/4X3/4 . . . . . . 4
070648 NUT/FLANGED LOCK . . . . . . . . . . . . . 4 651307 SCREW/PHILLIPS RH 1/4X1/2 . . . . . . 2
650315 SCREW/THREADED 1/4X1/2 . . . . . . . 3 16 132368 SUPPORT/CONSOLE. . . . . . . . . . . . . . . 1
4 135363 PAD/FRONT RIGHT . . . . . . . . . . . . . . . . 1 650294 SCREW/SELF-TAPPING 1/4X3/8. . . . 3
5 135464 PAD/FRONT LEFT . . . . . . . . . . . . . . . . . 1 17 132348 CONSOLE/RIGHT . . . . . . . . . . . . . . . . . . 1
6 135366 PAD/RIGHT REAR . . . . . . . . . . . . . . . . . 1 067750 NUT/SPEED . . . . . . . . . . . . . . . . . . . . . . 6
7 135463 PAD/LEFT REAR . . . . . . . . . . . . . . . . . . . 1 651308 SCREW/PHILLIPS RH 1/4X3/4 . . . . . . 4
8 135572 PAD/CROSSMEMBER . . . . . . . . . . . . . . 1 651307 SCREW/PHILLIPS RH 1/4X1/2 . . . . . . 2
9 135573 PAD/CROSSMEMBER . . . . . . . . . . . . . . 1 18 132369 SUPPORT/CONSOLE. . . . . . . . . . . . . . . 1
10 135615 PAD/ENGINE COVER . . . . . . . . . . . . . . 1 650294 SCREW/SELF-TAPPING 1/4X3/8. . . . 3
11 135617 PAD/GRILLE TO COOLER . . . . . . . . . . 2 19 135361 FOAM/ROPS LEFT . . . . . . . . . . . . . . . . . 1
12 132367 ASSY/TOOLBOX . . . . . . . . . . . . . . . . . . . 1 20 132429 FOAM/ROPS RIGHT . . . . . . . . . . . . . . . . 1
650294 SCREW/SELF-TAPPING 1/4X3/8. . . . 2 21 135649 PAD/FOAM DONUT . . . . . . . . . . . . . . . . 1
650959 SCREW/SELF-TAPPING 1/4X1-1/2 . . 2 093202 DECAL/ELECTRICAL CONTACT (ns) . 1
13 132244 HINGE . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1 093367 DECAL/WARNING MANUAL (ns) . . . . . 1
651307 SCREW/PHILLIPS RH 1/4X1/2 . . . . . . 3 093474 DECAL/WARNING GENERAL (ns) . . . . 1
071401 NUT/LOCK 1/4. . . . . . . . . . . . . . . . . . . . 3

25
12
24
13 Side-Mounted Cab Heater Kit 807833
16
14
25 12
16
18 7
8
17 19
2
2
22 21
26
4 2 9
23 20
1 10
HEATER PARTS ABOVE 6
9
10
3 5

REF 807833 KIT/CAB HEATER SIDE MOUNT 14 136305 SWITCH/HEATER . . . . . . . . . . . . . . . . . . 1
1 055648 TIE/WIRE . . . . . . . . . . . . . . . . . . . . . . . . . 1 15 136306 DECAL/HEATER SWITCH . . . . . . . . . . . 1
2 095955 CLAMP/HOSE . . . . . . . . . . . . . . . . . . . . . 4 16 136307 CORE/HEATER . . . . . . . . . . . . . . . . . . . . 1
3 132362 FITTING/STRAIGHT M18 X 1.50 . . . . . 2 17 136308 FAN MOTOR/HEATER . . . . . . . . . . . . . . 1
4 132503 HOSE/LOW PRESSURE 5/8 X 54 . . . . 2 18 136309 FAN BLADE/HEATER . . . . . . . . . . . . . . . 1
5 136196 HEATER/SIDE MOUNT . . . . . . . . . . . . . 1 19 136310 RESISTOR BLOCK/HEATER . . . . . . . . 1
6 136242 SLEEVE/NYLON PROTECTIVE . . . . . . 1 20 136311 RECTIFIER/HEATER . . . . . . . . . . . . . . . 1
7 136243 SLEEVE/NYLON PROTECTIVE . . . . . . 1 21 136312 FILTER/FRESH AIR . . . . . . . . . . . . . . . . 1
8 136292 VALVE ASSEMBLY/BALL . . . . . . . . . . . 1 22 136313 RETAINER CLIP/FILTER . . . . . . . . . . . . 1
9 650448 SCREW/CAP 1/4 X 3/4. . . . . . . . . . . . . . 2 23 136314 SCREW/THUMB . . . . . . . . . . . . . . . . . . . 2
10 654002 WASHER/FLAT 1/4 . . . . . . . . . . . . . . . . . 2 24 136316 SCREW/SEMS. . . . . . . . . . . . . . . . . . . . 29
11 136302 LOUVER/RECTANGULAR . . . . . . . . . . . 1 25 136321 SCREW #6 X 3/4 . . . . . . . . . . . . . . . . . . . 6
12 136303 LOUVER/3” ROUND W/ FLANGE . . . . . 2 26 650550 NUT/HEX #10 . . . . . . . . . . . . . . . . . . . . . 1
13 136304 KNOB/HEATER SWITCH . . . . . . . . . . . . 1 136315 WIRE HARNESS/HEATER (Not Shown)

OTHER AVAILABLE ACCESSORIES
Description Stock #
• Wet Filter Kit (Hydraulic, Oil and Fuel Filters) . . . . . . . . . . . . . . . . . . . . . . . 136232
• Cab Enclosure - Vinyl Sides & Door . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 806893
• Dirt and Rock Teeth . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 807378
• Engine Oil Pan Heater - 120 Volt . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 806835
Replacement Heater Cord, Order through Gehl Parts: Part #133932
• Engine Oil Pan Heater - 120 Volt (newer oil pans having a M22 x 1-1/2” threaded port) . . 808203
Replacement Heater Cord, Order through Gehl Parts: Part #133932
• Power Cable with Switch for “DX” Model Units - Additional Kit to Power Cold Planer, Rock Wheel
and Stump Grinder, Order through Gehl Parts: Part #129854
• Power Cable with Switch Handle for Units Utilizing Palm HD Grader . . . . . . . . . . . 806561
• Bolt-On Cutting Edge 63" for RG63 Recycling/Industrial Bucket, Order through Gehl Parts: Part
#131901
• Bolt-On Cutting Edge 72" for RG72 Recycling/Industrial Bucket, Order through Gehl Parts: Part
#131902
• Bolt-On Cutting Edge Kit for 60" Bucket. . . . . . . . . . . . . . . . . . . . . . . . . . . 133904
• Seat Belt - 3" - Where Required by Law . . . . . . . . . . . . . . . . . . . . . . . . . . . 805879
• Suspension Seat . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 806829
• Attachment All-Tach™ Mount Kit
(Weld-on to convert attachments to All-Tach™ Style) . . . . . . . . . . . . . . . . . . . . 806862
Specify Left or Right Side Mounting on Tire and Wheel Sets when ordering:
• Tire on Wheel 8.25 x 15 Chevron 6-Ply 1 Only . . . . . . . . . . . . . . . . . . . . . . . 805870
• Tire on Wheel 12 x 16.5 Flotation 6-Ply - 1 Only . . . . . . . . . . . . . . . . . . . . . . 805868
• Tire on Wheel 12 x 16.5 Galaxy 10-Ply HD - 1 Only . . . . . . . . . . . . . . . . . . . . 806381
• Tire on Wheel 33/15.5/16.5 Wide Galaxy 12-Ply HD - 1 Only . . . . . . . . . . . . . . . 806921
• Tire on Wheel 14 x 17.5 High Clearance 10-Ply HD- 1 Only . . . . . . . . . . . . . . . . 806393
• Tire on Wheel 8.00x 16 Solid - 1 Only . . . . . . . . . . . . . . . . . . . . . . . . . . . . 805872
• Tire on Wheel 31.5/13.00/16.5 Galaxy 10-Ply HD - 1 Only . . . . . . . . . . . . . . . . . 807159
• Tire on Wheel 10 x 31 Solid Rubber - 1 Only . . . . . . . . . . . . . . . . . . . . . . . . 807827
• Tire on Wheel 10 x 33 Solid Rubber - 1 Only . . . . . . . . . . . . . . . . . . . . . . . . 807828
• Tire on Wheel 8 x 31 Solid Rubber - 1 Only . . . . . . . . . . . . . . . . . . . . . . . . . 807829
• Tire on Wheel 7 x 26 Solid Rubber - 1 Only . . . . . . . . . . . . . . . . . . . . . . . . . 807830
• Tire on Wheel 12 x 16.5 Foamfill - 1 Only . . . . . . . . . . . . . . . . . . . . . . . . . . 808199
• Tire on Wheel 10 x 16.5 Foamfill - 1 Only . . . . . . . . . . . . . . . . . . . . . . . . . . 808200

SL46/4835 SKID LOADERS - INDEX
Part Page Ref. Part Page Ref. Part Page Ref. Part Page Ref.
No. No. No. No. No. No. No. No. No. No. No. No.
011296 32 4 064260 66 12 071401 12 10 075722 84 1
046588 4 14 064260 66 13 071401 36 1 075722 86 1
046588 4 15 064260 70 3 071401 42 1 076058 68 12
046588 4 23 064260 72 9 071401 56 9 076147 6 12
046588 4 24 064260 72 10 071401 58 22 076147 30 42
054202 38 5 064260 72 11 071401 58 23 076147 56 44
054626 12 14 064260 72 51 071401 64 10 076147 66 18
054626 26 13 064543 56 3 071401 64 11 076147 70 11
054626 28 13 065163 50 12 071401 68 6 076147 72 9
054626 30 13 065163 52 6 072340 68 7 076588 10 1
054816 12 6 065164 32 7 072343 2 3 076588 10 2
054985 70 5 065164 50 9 072580 14 5 076879 12 20
054994 12 13 065164 52 4 072580 16 5 076880 12 34
054994 24 17 067750 56 17 072580 18 6 077685 70 14
NUMERICAL INDEX
055005 10 5 067750 58 25 072587 10 14 077794 56 12
055005 14 1 067750 58 27 072587 14 40 078723 60 4
055005 16 1 067750 68 2 072587 16 44 078730 60 5
055005 18 1 067761 14 4 072587 20 71 078734 60 6
055306 90 19 067761 16 4 072794 75 2 078912 8 6
055306 92 18 067761 18 5 072797 75 3 078914 8 14
055648 70 1 067785 68 3 072853 76 47 078919 6 8
055648 70 13 067823 56 1 072854 76 48 078931 8 3
056937 38 3 067847 12 19 072866 40 24 078942 60 7
056937 40 25 067847 26 11 072866 50 19 078945 4 9
056937 44 7 067847 26 12 073036 68 8 078946 4 8
056937 46 1 067847 28 11 073075 75 6 079029 14 7
056937 48 9 067847 28 12 073458 75 35 079029 16 6
056937 60 1 067847 28 33 073687 72 8 079039 38 10
057557 56 2 067847 30 11 074091 6 21 079039 40 22
058615 34 9 067847 30 12 074091 24 15 079092 14 8
058615 56 43 067847 30 33 074091 68 9 079092 16 7
058805 68 1 067847 32 2 074091 70 13 079092 18 7
058805 70 9 067847 50 1 074093 38 16 079097 30 6
060745 90 11 067847 50 7 074093 44 21 079098 14 9
060745 92 11 067847 52 1 074093 46 2 079098 16 8
060746 90 12 067847 54 4 074093 48 17 079098 18 8
060746 92 12 067847 54 64 074395 28 33 079098 26 7
060748 92 27 067847 66 6 074395 30 33 079098 28 7
061166 8 23 067888 68 4 074579 68 10 079098 30 7
061574 14 2 067950 60 2 074830 14 41 079126 14 10
061574 16 2 068034 54 57 074830 16 45 079126 16 9
061574 18 2 068034 56 3 074830 20 74 079126 18 9
062023 6 9 068034 56 7 074860 54 7 079126 26 5
062282 50 17 068034 60 3 074868 34 2 079126 28 5
062282 52 9 068034 66 1 074868 34 3 079126 30 5
062397 18 3 068938 12 9 074868 38 11 079152 4 3
062756 54 60 068938 24 16 075028 70 4 079157 4 25
064260 14 9 070634 30 42 075104 68 11 079209 4 14
064260 16 8 070634 66 20 075236 14 6 079209 4 15
064260 18 8 070634 70 10 075236 28 46 079209 4 23
064260 32 1 070648 56 8 075236 30 46 079209 4 24
064260 32 4 070648 56 14 075288 40 23 079209 54 5
064260 56 20 070648 58 8 075288 44 6 079213 32 11
064260 66 8 070648 64 7 075288 46 3 079213 50 10
064260 66 11 070648 72 7 075288 48 3 079216 44 10
079216 46 5 091667 70 22 123067 92 1 127679 92 21
079216 48 6 093202 75 11 123069 90 2 127717 34 3
079288 18 10 093367 75 13 123069 92 2 127963 68 21
079614 32 6 093474 75 14 123070 90 4 127989 90 8
080327 98 11 093475 75 15 123070 92 4 127989 92 8
080330 98 6 093477 75 16 123073 90 7 127990 90 32
080331 98 2 093479 75 17 123073 92 7 127990 92 31
080333 98 5 094951 75 24 123079 90 9 128007 12 40
080556 12 39 095955 8 22 123079 92 9 128007 70 10
080808 100 1 097076 6 13 123080 90 10 128015 66 8
080809 100 2 114415 14 14 123080 92 10 128105 90 5
080810 100 3 114415 16 13 123084 90 17 128105 92 5
080811 100 4 114449 52 2 123084 92 16 128106 90 6
NUMERICAL INDEX
080813 100 6 114665 66 5 123087 92 26 128106 92 6

081433 70 7 115039 32 5 123093 92 29 128108 90 39
082339 6 20 121002 32 6 123094 90 29 128108 92 40
083108 4 5 121030 75 34 123110 90 36 128112 90 18
087393 12 11 121412 56 7 123110 92 34 128130 90 22
087812 4 7 121554 84 6 123114 92 36 128130 92 21
087849 8 12 121554 86 5 123122 90 3 128166 90 21
087849 26 17 121582 60 8 123122 92 3 128166 92 20
087849 28 17 121587 68 18 123123 90 16 128316 38 2
087849 30 17 121610 60 9 123123 92 15 128316 40 18
087854 54 6 121684 12 21 123129 90 27 128316 44 8
087974 32 10 121897 102 4 123380 76 45 128316 46 8
088040 68 14 122011 72 6 123381 76 46 128316 48 8
088046 12 38 122290 75 38 123383 40 20 128316 50 6
088101 54 3 122290 76 20 123501 66 16 128316 60 10
088254 32 9 122296 76 52 123554 54 53 128507 4 25
088471 100 7 122340 14 15 123722 44 15 128591 2 15
088472 100 8 122340 16 14 123722 46 6 128738 68 22
088473 100 9 122340 18 14 123722 48 15 128979 60 11
088904 14 11 122340 24 14 123817 68 11 128984 60 12
088904 16 10 122348 10 16 124078 50 18 129004 100 5
088904 18 11 122432 76 20 124078 52 10 129055 4 1
088904 26 22 122447 70 3 124089 68 19 129055 4 2
088904 28 22 122485 66 11 127342 2 16 129063 12 10
088904 30 22 122616 76 18 127349 14 17 129063 104
088912 40 21 122617 76 18 127349 16 16 129066 100 10
088912 50 7 122633 66 17 127349 18 16 129130 75 40
088937 8 18 122641 12 7 127360 32 4 129132 75 19
089001 14 39 122718 75 21 127360 58 33 129258 75 41
089001 16 43 122745 75 22 127428 8 4 129301 12 17
089001 20 73 122778 14 38 127455 68 20 129310 68 23
089010 56 14 122778 16 42 127488 32 8 129314 14 18
089012 56 15 122778 20 72 127488 34 7 129314 16 18
089071 68 15 122828 56 11 127488 38 15 129314 18 18
089082 68 16 122840 102 2 127488 40 19 129314 102
089083 68 17 122847 72 7 127488 50 11 129326 102 3
089961 100 11 122899 14 16 127488 52 5 129363 70 21
090047 96 6 122899 16 15 127556 10 15 129385 70 23
091035 75 9 122899 18 15 127623 34 6 129419 70 24
091050 75 10 122976 4 25 127629 98 10 129420 56 21
091421 66 15 122978 4 25 127669 44 11 129706 18 19
091666 70 20 123067 90 1 127679 90 22 129706 96
130032 68 24 131609 4 15 131945 56 18 132270 10 3
130033 94 3 131609 4 23 131951 8 4 132271 10 3
130033 96 12 131609 4 24 131952 28 29 132285 72 10
130034 94 2 131663 4 10 131952 30 29 132286 72 11
130034 96 1 131683 12 22 131953 28 30 132288 56 43
130035 96 9 131688 68 30 131953 30 30 132288 62 1
130036 96 3 131689 26 21 131958 30 39 132288 62 3
130037 96 10 131689 28 21 132016 76 36 132288 64 1
130038 96 11 131689 30 21 132018 75 29 132288 64 5
130039 96 5 131691 56 19 132023 6 17 132289 54 8
130040 96 7 131706 8 7 132024 6 18 132293 66 10
130041 96 4 131709 8 8 132027 4 16 132294 75 37
130046 96 8 131717 66 8 132035 10 8 132295 64 10
130050 94 8 131748 68 30 132036 10 10 132296 64 11
NUMERICAL INDEX
130050 96 13 131766 56 4 132037 10 11 132298 2 18
130055 96 14 131767 56 5 132038 10 8 132300 6 15
130059 96 2 131768 56 6 132039 10 10 132306 66 12
130064 68 25 131769 62 1 132040 10 11 132335 64 1
130085 56 8 131771 30 27 132046 72 1 132341 58 24
130166 104 3 131772 30 28 132047 72 2 132346 36 2
130167 104 1 131785 54 8 132048 72 3 132346 42 2
130297 75 4 131797 66 2 132049 12 29 132348 58 27
130342 68 26 131799 66 6 132050 2 20 132364 68 32
130354 68 50 131805 56 10 132051 2 21 132366 66 13
131018 68 27 131830 2 10 132053 12 28 132367 58 22
131050 68 28 131838 14 20 132062 26 27 132368 58 26
131059 10 1 131838 16 19 132062 28 27 132369 58 28
131060 56 1 131838 18 21 132063 70 13 132370 36 3
131083 4 25 131842 2 4 132069 34 11 132370 42 3
131088 34 13 131842 2 24 132072 8 8 132371 42 4
131093 34 2 131842 6 19 132073 34 12 132372 36 4
131110 50 13 131842 8 7 132075 34 8 132372 42 5
131110 52 7 131842 8 19 132078 62 2 132373 36 5
131139 4 4 131842 10 8 132078 64 2 132373 42 6
131159 68 29 131842 10 10 132088 54 10 132387 36 6
131176 54 5 131842 10 11 132089 56 22 132387 42 7
131201 54 12 131842 16 17 132104 34 1 132393 40 16
131248 66 4 131842 18 17 132139 75 30 132395 76 49
131262 50 8 131842 18 26 132148 30 41 132396 76 50
131262 52 11 131842 20 34 132149 34 10 132429 58 31
131278 66 1 131842 20 50 132161 58 8 132493 66 14
131443 54 9 131842 24 13 132162 68 50 132638 88 23
131460 70 12 131842 32 12 132166 75 33 132646 90 23
131488 86 8 131842 40 17 132167 62 3 132646 92 22
131492 12 5 131842 44 9 132167 64 5 132647 90 13
131493 12 4 131842 46 9 132179 56 20 132647 92 13
131522 2 13 131842 48 7 132187 76 36 132648 92 17
131522 106 3 131842 66 9 132199 104 2 132649 90 31
131529 26 37 131842 68 5 132200 68 31 132649 92 30
131529 28 37 131842 70 11 132210 22 3 132650 90 35
131529 90 28 131863 10 1 132210 98 132650 92 33
131529 92 28 131892 4 22 132211 98 1 132653 90 26
131571 12 19 131913 66 9 132213 20 66 132692 22 3
131577 14 19 131940 66 3 132244 58 23 132692 98
131609 4 14 131941 72 5 132248 92 37 132694 98 3
132695 98 4 134483 30 2 134621 18 32 134794 20 41
132989 6 16 134485 28 1 134622 16 30 134814 46 19
133030 64 12 134485 30 1 134622 18 33 134822 8 2
133064 98 4 134491 8 1 134642 8 17 134824 2 22
133074 6 11 134496 30 3 134643 20 34 134827 4 19
133557 6 14 134497 30 4 134645 12 16 134827 4 19
133957 4 3 134503 4 19 134647 12 32 134830 14 32
133966 4 1 134504 4 19 134648 12 33 134830 16 34
133966 88 134509 30 40 134649 12 12 134830 20 42
133970 54 1 134511 26 14 134658 44 12 134831 16 35
134060 76 43 134511 28 14 134658 46 14 134831 20 43
134201 2 1 134511 30 14 134658 48 10 134832 16 36
134219 54 51 134512 26 16 134659 44 13 134832 20 44
NUMERICAL INDEX
134230 4 11 134512 28 16 134659 46 15 134833 16 37

134241 40 15 134512 30 16 134659 48 11 134833 20 45
134241 50 5 134513 26 15 134681 56 37 134834 16 38
134243 50 4 134513 28 15 134681 68 33 134834 20 46
134286 92 134513 30 15 134685 8 1 134837 20 47
134299 2 7 134522 26 12 134691 8 5 134839 84 2
134327 38 4 134522 28 12 134694 2 50 134840 84 3
134327 44 2 134522 30 12 134696 26 36 134841 84 4
134331 2 1 134523 26 11 134696 28 36 134841 86 2
134345 2 9 134523 28 11 134696 30 36 134842 84 5
134356 54 2 134523 30 11 134697 26 34 134843 84 9
134368 26 10 134523 54 4 134697 28 34 134844 84 8
134368 28 10 134532 44 5 134697 30 34 134847 86 4
134368 30 10 134535 14 22 134698 28 31 134848 84 7
134368 84 134535 16 22 134698 30 31 134849 86 7
134371 4 25 134535 18 24 134702 26 32 134851 44 10
134372 4 25 134536 2 51 134702 28 32 134851 46 20
134398 50 14 134548 2 51 134702 30 32 134851 48 6
134398 52 8 134558 2 5 134707 54 57 134852 2 51
134400 44 9 134579 54 13 134709 10 7 134852 14 39
134400 46 11 134588 14 18 134710 10 12 134852 16 43
134400 48 7 134588 16 18 134724 20 35 134852 20 73
134426 2 11 134588 18 18 134728 30 37 134852 22 2
134427 2 11 134588 34 8 134729 30 43 134852 24 12
134436 44 16 134588 36 7 134748 6 1 134852 38 9
134436 46 12 134588 70 12 134749 6 1 134852 40 14
134436 48 5 134594 54 52 134756 2 6 134852 44 2
134437 44 17 134599 18 26 134757 44 14 134852 44 4
134437 46 13 134599 106 134760 32 12 134852 44 18
134437 48 14 134613 14 24 134774 20 36 134852 44 19
134447 50 15 134613 16 24 134775 20 37 134852 46 21
134455 26 26 134613 18 27 134776 20 38 134852 48 4
134455 28 26 134614 14 25 134777 20 39 134852 48 16
134455 30 26 134614 16 25 134792 38 6 134852 48 21
134456 26 25 134614 18 28 134792 44 4 134852 50 14
134456 28 25 134615 14 26 134792 46 17 134852 52 8
134456 30 25 134615 16 26 134792 48 4 134852 70 5
134464 28 8 134615 18 29 134793 14 30 134852 70 16
134464 30 8 134616 14 27 134793 16 32 134852 70 21
134474 28 9 134616 16 27 134793 20 40 134853 2 2
134474 30 9 134616 18 30 134794 14 31 134853 10 4
134483 28 2 134621 16 29 134794 16 33 134853 12 23
134853 12 25 134983 48 16 135183 10 13 135361 58 30
134853 44 20 134988 20 50 135184 75 28 135362 58 25
134853 46 22 134991 20 69 135234 6 19 135363 64 8
134853 48 18 135006 2 51 135240 56 16 135365 66 7
134853 52 3 135007 20 51 135241 68 36 135366 64 13
134853 66 2 135008 68 35 135247 2 50 135367 16 17
134855 26 23 135009 20 52 135252 56 38 135367 18 17
134855 28 23 135010 70 8 135259 8 21 135367 100
134855 30 23 135017 12 8 135261 8 27 135368 98 8
134856 26 24 135018 20 53 135262 8 20 135369 98 9
134856 28 24 135025 10 9 135263 8 28 135371 98 7
134856 30 24 135029 90 135270 2 7 135372 8 25
134857 28 34 135030 20 52 135272 12 15 135374 62 4
134857 30 34 135031 20 68 135284 12 27 135374 64 15
NUMERICAL INDEX
134858 28 36 135032 14 37 135293 2 14 135375 64 6
134858 30 36 135032 16 41 135297 14 28 135377 8 24
134865 38 13 135032 18 20 135297 16 28 135380 66 7
134866 38 14 135038 72 50 135297 18 31 135381 66 19
134874 54 54 135039 72 51 135300 54 64 135383 10 15
134878 14 34 135058 26 18 135306 26 19 135384 8 26
134878 16 40 135058 28 18 135306 28 19 135385 10 17
134878 94 135058 30 18 135306 30 19 135387 12 35
134879 20 49 135058 86 0 135309 32 2 135393 38 12
134880 20 65 135061 86 3 135310 32 1 135393 44 3
134888 44 1 135062 86 6 135311 4 2 135394 64 7
134889 38 1 135069 48 2 135312 32 3 135407 6 3
134914 50 1 135081 38 13 135318 36 8 135425 6 7
134923 14 35 135082 38 14 135318 42 8 135427 6 22
134924 94 4 135086 8 2 135318 46 10 135427 12 37
134925 94 6 135087 8 5 135325 70 6 135432 12 10
134926 94 5 135090 2 51 135331 14 12 135432 14 18
134927 94 1 135108 10 2 135331 16 11 135432 16 18
134938 76 25 135113 12 2 135331 18 12 135432 18 18
134939 76 25 135114 12 3 135332 46 16 135432 70 12
134940 76 25 135119 10 2 135332 48 13 135436 12 25
134941 76 25 135125 34 5 135336 88 1 135440 12 25
134964 76 25 135131 8 10 135338 88 5 135445 90 30
134965 76 25 135132 8 9 135339 88 7 135448 12 26
134966 6 2 135135 4 23 135340 88 8 135451 12 23
134966 6 3 135136 4 24 135341 88 9 135457 106 1
134966 10 4 135137 40 13 135342 88 10 135458 106 2
134966 12 1 135139 14 13 135343 88 11 135459 106 4
134966 12 26 135139 16 12 135344 88 12 135460 106 5
134966 26 19 135139 18 13 135345 88 13 135461 106 6
134966 28 19 135140 40 12 135346 88 15 135462 106 7
134966 30 19 135142 4 15 135347 88 16 135463 64 14
134969 76 25 135143 4 14 135348 88 17 135464 64 9
134970 76 25 135145 40 11 135349 88 18 135465 4 25
134971 76 25 135157 8 19 135350 88 19 135572 64 4
134972 76 25 135158 40 11 135351 88 2 135573 64 3
134973 76 25 135167 8 9 135352 88 3 135600 66 20
134977 68 34 135171 52 3 135353 88 4 135604 46 18
134980 14 36 135177 56 13 135354 88 6 135605 46 7
134983 44 18 135179 20 70 135355 88 14 135605 48 12
134983 46 23 135182 10 13 135357 88 21 135607 46 36
135607 48 22 136601 6 7 650225 36 13 650491 52 1
135615 64 16 136601 12 24 650225 42 11 650492 44 18
135617 64 19 136765 54 50 650294 58 26 650492 46 26
135649 64 20 136766 54 50 650294 58 28 650492 48 16
135687 88 22 136978 90 5 650315 64 7 650492 54 64
135772 50 16 136978 92 5 650387 50 12 650494 2 17
135773 12 41 136979 90 18 650387 52 6 650494 52 3
135773 54 13 136980 90 21 650394 56 20 650495 2 2
135803 4 12 136980 92 20 650394 68 7 650495 12 23
135814 2 23 136981 90 23 650426 70 10 650495 12 25
135838 2 2 136981 92 22 650433 92 38 650495 56 7
135993 10 4 136982 90 25 650449 14 18 650499 56 1
135996 36 9 136982 92 24 650449 16 18 650533 38 7
NUMERICAL INDEX
136003 36 10 136983 90 26 650449 18 18 650533 44 2

136008 36 11 136984 90 25 650453 2 10 650533 44 4
136008 42 9 136984 92 24 650453 2 11 650533 46 27
136011 36 12 136985 90 20 650453 10 4 650533 48 4
136011 42 10 136985 92 19 650453 12 1 650535 26 12
136013 2 8 136986 90 33 650453 12 26 650535 28 12
136054 24 11 136986 92 32 650453 44 20 650535 30 12
136054 98 136987 90 34 650453 46 24 650535 92 14
136056 6 6 136988 90 38 650453 48 18 650542 34 8
136063 6 4 136994 90 24 650483 54 5 650542 36 15
136072 24 10 136994 92 23 650484 36 14 650545 26 7
136101 12 36 136995 90 35 650484 42 12 650545 28 7
136107 6 10 136995 92 33 650485 34 2 650545 30 7
136116 4 3 137015 92 25 650486 2 24 650547 26 7
136128 62 1 137016 92 25 650486 8 19 650547 28 7
136128 62 2 137017 92 17 650486 24 3 650547 30 7
136128 64 2 137018 10 6 650486 32 12 650547 30 41
136134 40 10 137018 14 29 650486 54 10 650549 50 12
136138 40 9 137018 16 31 650487 20 34 650549 52 2
136143 24 8 137018 20 67 650487 32 1 650549 52 6
136148 24 7 137190 54 50 650487 70 11 650549 68 37
136149 24 6 137211 54 56 650488 2 22 650549 70 1
136150 24 5 137212 54 55 650490 14 39 650550 68 38
136151 24 4 137214 54 54 650490 16 43 650551 32 8
136190 40 8 137291 24 9 650490 20 73 650551 34 6
136201 2 24 137545 75 1 650490 22 1 650551 34 7
136202 2 25 137660 75 42 650490 24 2 650551 38 15
136226 70 16 138177 68 13 650490 48 21 650551 40 4
136234 70 1 138200 88 24 650490 50 14 650551 50 3
136239 52 1 138344 102 1 650490 52 8 650551 60 13
136244 2 4 138405 88 25 650490 54 9 650552 50 3
136251 40 7 138406 88 26 650490 70 5 650554 4 13
136251 50 2 139108 50 3 650490 70 16 650568 6 19
136253 40 6 139181 6 2 650490 70 21 650568 14 9
136293 12 18 520013 4 6 650491 14 34 650568 16 8
136318 98 4 570002 26 38 650491 16 40 650568 18 8
136351 34 4 570002 28 38 650491 18 19 650568 24 1
136387 12 1 570002 30 38 650491 38 10 650568 28 7
136388 92 570002 54 4 650491 40 5 650568 30 7
136389 90 570002 54 11 650491 44 19 650573 48 7
136467 12 24 570002 86 9 650491 46 25 650573 66 12
136475 50 2 603024 94 7 650491 50 1 650573 66 13
650573 68 39 651041 2 7 653039 38 14 656110 6 12
650577 18 26 651041 2 9 653039 40 1 656110 6 19
650580 36 16 651041 2 50 654002 34 2 656141 6 6
650580 42 13 651041 2 51 654002 44 14 656149 50 13
650585 66 1 651041 14 20 654002 46 35 656149 52 7
650630 58 8 651041 16 19 654002 48 13 656188 12 23
650634 38 6 651041 18 21 654002 50 13 660080 2 12
650634 44 4 651085 4 1 654002 58 22 703692 56 22
650634 46 29 651168 54 12 654002 70 10 L62459 56 9
650634 48 4 651168 56 44 654004 32 1 L65922 75 12
650648 32 7 651168 68 42 654004 38 7 L65928 75 51
650648 50 9 651168 70 9 654004 46 32 L99453 8 29
650648 50 12 651212 68 43 654004 50 3 L99967 8 30
650648 52 2 651213 68 44 654004 48 4
NUMERICAL INDEX
M12070 70 10
650648 52 4 651297 54 54 654004 66 12
650648 52 6 651307 56 17 654004 70 3
650648 70 1 651307 58 23 654006 12 19
650658 56 20 651307 58 25 654006 28 33
650658 68 7 651307 58 27 654006 30 33
650687 2 4 651307 64 10
654006 32 2
650687 44 9 651307 64 11
654009 54 57
650687 46 30 651307 66 20
654009 56 7
650687 68 40 651308 58 25
654009 56 11
650687 72 7 651308 58 27
654009 66 1
650687 72 51 651308 68 45
650692 32 4 651312 2 8 654009 66 2
650702 2 20 651314 68 46 654009 92 39
650702 34 10 651343 68 47 654012 56 1
650706 12 10 651344 68 48 654022 52 7
650731 90 14 651363 64 1 654024 30 41
650733 16 17 651364 54 59 654024 66 11
650733 18 17 651366 26 19 654026 54 9
650733 20 50 651366 28 19 654030 2 10
650742 90 15 651366 30 19 654030 2 11
650758 30 42 651372 54 13 654042 68 49
650758 70 12 651378 6 2 654042 70 4
650771 56 9 651378 6 3 654042 70 5
650811 66 2 651379 6 7 654042 70 6
650818 26 11 651379 12 24 654044 68 7
650818 28 11 651381 4 13 654046 2 17
650818 30 11 651523 40 2 654046 58 8
650818 54 4 651526 4 14 655001 50 11
650833 16 8 651526 4 15 655001 52 5
650833 18 8 651526 4 23 655006 56 11
650834 66 2 651526 4 24
656048 20 63
650835 36 17 651542 54 52
656048 44 14
650835 42 14 651573 40 3
656048 46 33
650839 36 18 653034 66 9
656048 48 13
650848 68 41 653036 44 15
656049 20 64
650850 56 3 653036 44 16
650850 56 11 653036 44 17 656093 6 12
650854 90 37 653036 46 31 656093 6 19
650854 92 35 653036 48 6 656098 6 4
650959 58 22 653039 38 5 656100 70 1
651041 2 5 653039 38 13 656105 70 4

Recommended Coupling & Adapter Installation Torque Specifications
For JIC 37° and 45°

For SAE “0" Ring Boss (Steel) (Machined or Flared)
Size Ft-Lbs Steel
Dash
Fractional
Minimum Maximum Size Ft-Lbs
(In.)
Fractional
-3 3/16 8 10 Dash Minimum Maximum
(In.)
-4 1/4 14 16 -4 1/4 10 11
-5 5/16 18 20 -5 5/16 13 15
-6 3/8 24 26 -6 3/8 17 19
-8 1/2 50 60 -8 1/2 34 38
-10 5/8 72 80 -10 5/8 50 56
-12 3/4 125 135 -12 3/4 70 78
-14 7/8 160 180 -16 1 94 104
-16 1 200 220 -20 1-1/4 124 138
-20 1-1/4 210 280 -24 1-1/2 156 173
-24 1-1/2 270 360 -32 2 219 243

Torque Specifications
Use these torque values when tightening GEHL hardware (excluding: Lock Nuts, and Self-tapping,
Thread Forming, and Sheet Metal Screws) unless otherwise specified.
Unified Grade 2 Grade 5 Grade 8

National
Thread Dry Lubed Dry Lubed Dry Lubed
8-32 19* 14* 30* 22* 41* 31*
8-36 20* 15* 31* 23* 43* 32*
10-24 27* 21* 43* 32* 60* 45*
10-32 31* 23* 49* 36* 68* 51*
1/4-20 66* 50* 9 75* 12 9
1/4-28 76* 56* 10 86* 14 10
5/16-18 11 9 17 13 25 18
5/16-24 12 9 19 14 25 20
3/8-16 20 15 30 23 45 35
3/8-24 23 17 35 25 50 35
7/16-14 32 24 35 35 70 55
7/16-20 36 27 40 40 80 60
1/2-13 50 35 75 55 110 80
1/2-20 55 40 90 65 120 90
9/16-12 70 55 110 80 150 110
9/16-18 80 60 120 90 170 130
5/8-11 100 75 150 110 220 170
5/8-18 110 85 180 130 240 180
3/4-10 175 130 260 200 380 280
3/4-16 200 150 300 220 420 320
7/8-9 170 125 430 320 600 460
7/8-14 180 140 470 360 660 500
1-8 250 190 640 480 900 680
1-12 270 210 710 530 1000 740
Metric Grade 8.8 Grade 10.9 Grade 12.9

Coarse
Thread Dry Lubed Dry Lubed Dry Lubed
M6-1 8 6 11 8 13.5 10
M8-1.25 19 14 27 20 32.5 24
M10-1.5 37.5 28 53 39 64 47
M12-1.75 65 48 91.5 67.5 111.5 82
M14-2 103.5 76.5 145.5 108 176.5 131
M16-2 158.5 117.5 223.5 165.5 271 200
*All Torque Values are in ft-lbs except those marked with an * which are in in-lbs.
For metric torque value (N·m) multiply ft-lbs value by 1.355 or the in-lbs value by 0.113.
®
Gehl Company 143 Water Street, P.O. Box 179, West Bend, WI 53095-0179 USA
www.gehl.com
907807/HP1002 © 2002 GEHL COMPANY PRINTED IN USA

All Rights Reserved.

SL4635 & SL4835 Parts Manual

Uploaded by

Copyright:

Available Formats

SL4635 & SL4835 Parts Manual

Uploaded by

Document Information

Copyright

Available Formats

Share this document

Share or Embed Document

Sharing Options

Did you find this document useful?

Is this content inappropriate?

Copyright:

Available Formats

SL4635 & SL4835 Parts Manual

Uploaded by

Copyright:

Available Formats

What parts are covered in the parts book?

What parts are covered in the parts book?

What information is provided for each part?

What information is provided for each part?

Form No.

GEHL is a registered trademark of the Gehl Company.

SECTION A: MAIN LOADER COMPONENTS

SECTION B: HYDRAULIC COMPONENTS

All-Tach is a trademark of the Gehl Company.

Numerical Index . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 128

Quick-Tach is a trademark of the Gehl Company.

SECTION A: MAIN LOADER COMPONENTS

907807/HP1002 1 PRINTED IN USA

Ref. Part Quantity Quantity

Ref. Part Quantity Quantity

PRINTED IN USA 2 907807/HP1002

Left Side Wheel Drive 2

907807/HP1002 3 PRINTED IN USA

Ref. Part Quantity Quantity

PRINTED IN USA 4 907807/HP1002

907807/HP1002 5 PRINTED IN USA

Ref. Part Quantity Quantity

ENGINE IDLE AND HIGH IDLE RPM CHART

PRINTED IN USA 6 907807/HP1002

907807/HP1002 7 PRINTED IN USA

Ref. Part Quantity Quantity

PRINTED IN USA 8 907807/HP1002

To Engine Port - Fan End

To Engine Port - Flywheel End

907807/HP1002 9 PRINTED IN USA

Ref. Part Quantity Quantity

PRINTED IN USA 10 907807/HP1002

907807/HP1002 11 PRINTED IN USA

Ref. Part Quantity Quantity

PRINTED IN USA 12 907807/HP1002

907807/HP1002 13 PRINTED IN USA

Ref. Part Quantity

PRESSURE SETTINGS AMOUNT OF PRESSURE

PRINTED IN USA 14 907807/HP1002

SX & SXT Models

907807/HP1002 15 PRINTED IN USA

Ref. Part Quantity

PRESSURE SETTINGS AMOUNT OF PRESSURE

PRINTED IN USA 16 907807/HP1002

907807/HP1002 17 PRINTED IN USA

Ref. Part Quantity Quantity

Parts List Continued on Next Page

PRESSURE SETTINGS AMOUNT OF PRESSURE

PRINTED IN USA 18 907807/HP1002

907807/HP1002 19 PRINTED IN USA

Ref. Part Quantity Quantity

PRESSURE SETTINGS AMOUNT OF PRESSURE

PRINTED IN USA 20 907807/HP1002

Main Control Valve - T-Bar and Dual Hand

907807/HP1002 21 PRINTED IN USA

Ref. Part Quantity Quantity

PRINTED IN USA 22 907807/HP1002

Main Control Valve - Hand and Foot

907807/HP1002 23 PRINTED IN USA

Ref. Part Quantity