DI16

DIAGNOSTICS ENGINE (2RZFE, 3RZFE)

DI12C31

DIAGNOSTIC TROUBLE CODE CHART

HINT: Parameters listed in the chart may not be exactly the same as your readings due to the type of instrument or other factors. If a malfunction code is displayed during the DTC check in the check mode, check the circuit for the codes listed in the table below. For details of each code, refer to the See page under the respective DTC No. in the DTC chart.
DTC No. (See page) Detection Item Trouble Area S Open or short in heater circuit of heated oxygen sensor S Heated oxygen sensor heater S EFI main relay S ECM S Open or short in mass air flow meter circuit S Mass air flow meter S ECM S Mass air flow meter S Open or short in intake air temp. sensor circuit S Intake air temp. sensor (built into mass air flow meter) S ECM S Open or short in engine coolant temp. sensor circuit S Engine coolant temp. sensor S ECM S Cooling system S Engine coolant temp. sensor S Open or short in throttle position sensor circuit S Throttle position sensor S ECM S Throttle position sensor MIL*1 Memory

P0036 (DI25)

Oxygen Sensor Heater Control Circuit (Bank 1 Sensor 2)

P0100 (DI28) P0101 (DI32) P0110 (DI33)

Mass or Volume Air Flow Circuit Mass or Volume Air Flow Circuit Range/Performance Problem

Intake Air Temperature Circuit

P0115 (DI38)

Engine Coolant Temperature Circuit Engine Coolant Temperature Circuit Range/Performance Problem Throttle Pedal Position Sensor/ Switch A Circuit Throttle Pedal Position Sensor/ Switch A Circuit Range/Performance Problem Insufficient Coolant Temperature for Closed Loop Fuel Control Coolant Thermostat (Coolant Temperature Below Thermostat Regulating Temperature)

P0116 (DI42) P0120 (DI44)

P0121 (DI48) P0125 (DI42)

S Same as DTC No. P0116 S Thermostat S Cooling system S Engine coolant temp. sensor S ECM S Open or short in A/F sensor (bank 1 sensor 1) circuit S A/F sensor (bank 1 sensor 1) S A/F sensor heater S EFI main relay S A/F sensor heater and relay circuit S Air induction system S Fuel pressure S Injector S Gas leak in exhaust system S PCV hose connection S PCV valve and hose S ECM

P0128 (DI49)

P0134 *4 (DI50)

Oxygen Sensor Circuit No Activity Detected (Bank 1 Sensor 1)

2003 TOYOTA TACOMA (RM1002U)

Author:

Date:

278

DI17
DIAGNOSTICS ENGINE (2RZFE, 3RZFE)

P0135 (DI61) P0136 (DI64)

Oxygen Sensor Heater Circuit (Bank 1 Sensor 1) Oxygen Sensor Circuit Malfunction (Bank 1 Sensor 2)

S Open or in heater circuit of A/F sensor S A/F sensor heater S ECM S Open or short in heated oxygen sensor circuit S Heated oxygen sensor S Air induction system S Injector blockage S Mass air flow meter S Engine coolant temp. sensor S Fuel pressure S Gas leakage in exhaust system S Open or short in A/F sensor (bank 1 sensor 1) circuit S A/F sensor (bank 1 sensor 1) S PCV valve and hose S PCV hose connection S EFI main relay S A/F sensor heater and relay circuit S Injector leak or blockage S Mass air flow meter S Engine coolant temp. sensor S Ignition system S Fuel pressure S Gas leakage in exhaust system S Open or short in A/F sensor (bank 1 sensor 1) circuit S A/F sensor (bank 1 sensor 1) S EFI main relay S A/F sensor heater and relay circuit S Open or short in engine wire S Connector connection S Vacuum hose connection S Ignition system S Injector S Fuel pressure ressure S EGR system (Only for 3RZFE) S Mass air flow meter S Engine coolant temp. tem . sensor S Compression pressure S Valve clearance S Valve timing S PCV hose connection S PCV hose S ECM S Open or short in knock sensor circuit S Knock sensor (looseness) S ECM S Open or short in crankshaft position sensor circuit S Crankshaft position osition sensor S Signal plate (Crankshaft position sensor rotor) S ECM S Open or short in camshaft position sensor circuit S Camshaft position osition sensor S Camshaft S Jumping teeth of timing chain S ECM

P0171 (DI68)

System too Lean (Bank 1)

P0172 (DI68)

System too Rich (Bank 1)

P0300 (DI77) P0301 (DI77) P0302 (DI77) P0303 (DI77) P0304 (DI77) P0325 (DI87) P0335 (DI90) P0339 (DI90) P0340 (DI93) P0341 (DI93)

Random/Multiple Cylinder Misfire Detected

Cylinder 1 Misfire Detected

Cylinder 2 Misfire Detected

f*2

Cylinder 3 Misfire Detected

Cylinder 4 Misfire Detected

Knock Sensor 1 Circuit (Bank 1 or Single Sensor) Crankshaft Position Sensor A Circuit Crankshaft Position Sensor A Circuit Intermittent Camshaft Position Sensor A Circuit (Bank 1 or Single Sensor) Camshaft Position Sensor A Circuit Range/Performance (Bank 1 or Single Sensor)

f f

f f f

2003 TOYOTA TACOMA (RM1002U)

Author:

Date:

279

DI18
DIAGNOSTICS ENGINE (2RZFE, 3RZFE)

P0351 (DI95)

Ignition Coil A Primary/Secondary Circuit

S Ignition system S Open or short in IGF and IGT1 circuit from ignition coil with igniter S ignition coil with igniter S ECM S Ignition system S Open or short in IGF and IGT 2 circuit from No. 2 ignition coil with igniter to ECM S NO. 2 ignition coil with igniter S ECM S Ignition system S Open or short in IGF and IGT 3 circuit from No. 3 ignition coil with igniter to ECM S NO. 3 ignition coil with igniter S ECM S Ignition system S Open or short in IGF and IGT 4 circuit from No. 4 ignition coil with igniter to ECM S NO. 4 ignition coil with igniter S ECM S Open in EGR gas temp. sensor circuit S EGR gas temp. sensor S Vacuum or EGR hose disconnected S Open or short in VSV circuit for EGR S VSV for EGR S EGR system S EGR vacuum modulator S EGR valve stuck closed S ECM S Short in EGR gas temp. sensor circuit S EGR gas temp. sensor S Open in VSV circuit for EGR S VSV for EGR S EGR valve stuck open S ECM S Gas leakage on exhaust system S A/F sensor (bank 1 sensor 1) S Heated oxygen sensor (bank 1 sensor 2) S Threeway catalytic converter S Fuel tank cap incorrectly installed S Fuel tank cap cracked or damaged S Vacuum hose cracks, holed blocked, damaged or disconnected S Open or short in vapor pressure sensor circuit S Vapor pressure sensor S Open or short in VSV circuit for EVAP S VSV for EVAP S Open or short in VSV circuit for CCV S VSV for CCV S Open or short in VSV circuit for pressure switching valve S VSV for pressure switching valve S Fuel tank cracked, holed or damaged S Charcoal canister cracked, holed or damaged S Fuel tank over fill check valve cracked or damaged S ECM

P0352 (DI95)

Ignition Coil B Primary/Secondary Circuit

P0353 (DI95)

Ignition Coil C Primary/Secondary Circuit

P0354 (DI95)

Ignition Coil D Primary/Secondary Circuit

P0401 (DI101)

Exhaust Gas Recirculation Flow Insufficient Detected (Only for 3RZFE)

P0402 (DI111)

Exhaust Gas Recirculation Flow Excessive Detected (Only for 3RZFE)

P0420 (DI115)

Catalyst System Efficiency Below Threshold (Bank 1)

P0441 (DI118)

Evaporative Emission Control System Incorrect Purge Flow

2003 TOYOTA TACOMA (RM1002U)

Author:

Date:

280

DI19
DIAGNOSTICS ENGINE (2RZFE, 3RZFE)

P0442 (DI151)

Evaporative Emission Control System Leak detected (Small Leak)

S Fuel tank cap incorrectly installed S Fuel tank cap cracked or damaged S Hose or tube cracked, hole, damaged or loose seal S Vacuum hose cracked, holed, blocked, damaged or disconnected S Fuel tank cracked, holed or damaged S Charcoal canister cracked, holed or damaged S Open or short in vapor pressure sensor circuit S VSV for CCV S VSV for EVAP S VSV for pressure switching valve S Vapor pressure sensor S Fuel tank over fill check valve cracked or damaged S ECM S Same as DTC No. P0441

P0446 (DI118) P0450 (DI165) P0451 (DI165) P0456 (DI151)

Evaporative Emission Control System Vent Control Circuit Evaporative Emission Control System Pressure Sensor Malfunction Evaporative Emission Control System Pressure Sensor Range/ Performance Evaporative Emission Control System Leak detected (very small leak)

S Open or short in vapor pressure sensor circuit S Vapor V pressure sensor S ECM

S Same as DTC No. P0442 S Combination meter S Open or short in No. 1 vehicle speed sensor circuit S ECM S No. 1 vehicle speed sensor S PCV hose connection S PCV hose S Open or short in IAC valve circuit S IAC valve l is i stuck t k or closed l d S Open or short in A/C switch circuit S Air induction system S ECM S Open in back up power source circuit S ECM S Short in Park/neutral position (PNP) switch (A/T) or Clutch start switch (M/T) circuit S Park/neutral position (PNP) switch (A/T) S Clutch start switch (M/T) S Ignition switch S ECM S Open in park/neutral position switch circuit S Park/neutral position switch S ECM S Short in stop light switch signal circuit S Stop light switch S ECM S Open in park/neutral position switch circuit S Park/neutral position switch S ECM

P0500 (DI167)

Vehicle Speed Sensor A

P0505 (DI169)

Idle Air Control System

P0511 (DI169) P0560 (DI173)

Idle Air Control Circuit

System Voltage

P0617 (DI175)

Starter Relay Circuit High

P0705 *3 (DI181)

Transmission Range Sensor Circuit Malfunction (PRNDL Input)

P0724 *3 (DI182)

Brake Switch B Circuit High

P0850 *3 (DI181)

Park/Neutral Switch Input Circuit Low

2003 TOYOTA TACOMA (RM1002U)

Author:

Date:

281

DI20
DIAGNOSTICS ENGINE (2RZFE, 3RZFE)

P2195 *4 (DI185)

Oxygen Sensor Signal Stuck Lean (Bank 1 Sensor 1)

P2196 *4 (DI185)

Oxygen (Sensor Signal Stuck Rich (Bank 1 Sensor 1)

S Open or short in A/F sensor circuit S A/F sensor S A/F sensor heater S EFI main relay S Air induction system S Fuel pressure S Injector S ECM S Open or short in A/F sensor circuit S A/F sensor S A/F sensor heater S EFI main relay S Open or short in A/F sensor circuit S A/F sensor S A/F sensor heater S EFI main relay S Air induction system S Fuel pressure S Injector S ECM

P2237 *4 (DI194)

Oxygen Sensor Pumping Current Circuit / Open (for A/F sensor) (Bank 1 Sensor 1)

P2A00 (DI198)

A/F Sensor Circuit Slow Response (Bank 1 Sensor 1)

*1: *2: *3: *4:

.... MIL does not light up. f .... MIL lights up MIL lights up or blinks. A/T only. This DTC is related to A/F sensor is in a malfunction, although the detection item is oxygen sensor.

2003 TOYOTA TACOMA (RM1002U)

Author:

Date:

282