Air-Cooled Series R(TM)

Job Information
Name
Address
Sales Team
Comments

Job01
TIG

Tag
Quantity
Model Number

RTAC140 STD
1
RTAC140

140
122.30 tons
174
2.23 COP
13.7 EER
165.0 lb

General
Distribution Channel
Unit type
Agency listing
Efficiency
IPLV
Refrig (HFC-134a) - ckt
1
Oil charge - ckt 1
Shipping weight
Length
Height

United States
Standard efficiency
C/UL listing
7.6 EER
13.6 EER
165.0 lb

A-weighted sound
power
AHRI certified selection

100 dBA

Unit nominal tonnage

Capacity
TOPSS version number
COP
NPLV
Refrig (HFC-134a) - ckt
2
Oil charge - ckt 2
Operating weight
Width
A-weighted sound
pressure
AHRI certification

AHRI certified
selection
138.30 tons

ASHRAE 90.1/CSA
compliance
Rated efficiency (AHRI)

All versions to 2010

Low temp
55.00 F
0.00010 hr-sq ft-deg
F/Btu
0.00 %
Factory installed flow
switch- water
32.00 F
3.90 ft H2O

Evap leaving temp

Evap flow rate
Evap fluid type

45.00 F
292.40 gpm
Water

Evap configuration
Evap pressure drop

2pass 0.75 insulation

8.50 ft H2O

Min evap flow rate

Max evap flow rate

193.00 gpm
709.00 gpm

43.70 ft H2O

Saturated evap temp ckt 1

41.30 F

Elevation
Cond ambient range
Saturated cond temp ckt 1

135.00 ft
High ambient
147.50 F

Incoming power line

connection
Power line connection
type*
Unit power
Fan motor power
Number of cond fansNFN1 - ckt 1
RLA - condenser fan
(each)
RLA - compressor B

Single point

Rated capacity (AHRI)

1.30 gal
10832.0 lb
196.000 in
93.000 in

1.30 gal
11146.0 lb
89.000 in
72 dBA
AHRI certified

9.7 EER

Evaporator
Evap application
Evap entering temp
Evap fouling factor
Evap fluid concentration
Flow switch
Evap. fluid freeze point
Press drop min evap
flow
Press drop max evap
flow
Saturated evap temp ckt 2

42.10 F

Condenser
Ambient air temp
Cond fin material
Cond fan/motor config

110.00 F
Aluminum slit fins
Fans w/ TEAO motors

Saturated cond temp ckt 2

147.90 F

Electrical
Unit voltage

460v/60hz/3ph

Compressor starter
type
Short circuit
Compressor power
Number of condenser
fans
Number of cond fansNFN2 - ckt 2
RLA - compressor A

Wye-delta
Default
181.00 kW
8.00 Each
4.00 Each
118.00 A

Circuit breaker(s) HACR rated

192.90 kW
11.10 kW
4.00 Each
2.70 A
118.00 A

Page 1

LRA - compressor A
XLRA - compressor A
Single point power MCA
Short circuit rating

252.00 A
774.00 A
293.00 A
10000.00 A

LRA - compressor B
XLRA - compressor B
Single point power MOP

252.00 A
774.00 A
400.00 A

Air cooled Series

R(TM) model RTAC
Factory/ABU assigned

Startup and
commissioning

Unit startup by Trane

Control, label, and

literature

English

Base Unit Module

Chiller model
Design sequence

Evaporator Module
Pressure vessel code

ASME code

Controls Module
Unit operator interface

Dyna-View operator
interface

Miscellaneous Options
Refrigerant service
valves

Refrigerant isolation
valves

Page 2

Page 3

SIDE VIEW

TOP (PLAN) VIEW

4 in (100 mm) NPS

152 mmx 140 mm

LIFTING PLATE DIMENSIONS

17 mm

MOUNTING HOLE DIAMETER

WATER CONNECTION DIAMETER

WATER VOLUME STORAGE

END VIEW

ISOMETRIC VIEW

29 GAL (110 LITERS)

Page 4

39 mm

953 mm

SIDE VIEW

4755 mm

2702 mm

LIFTING PLATE
4 PLACES

MOUNTING HOLES
8 PLACES

19 1 m m

1 04 5 mm

Page 5

270 mm

RELIEF VALVE
3/8" (9.5mm)
SAE MFL

C ON DEN SER REM OVED

TOP (PLAN) VIEW

4476 mm
4629 mm

RELIEF VALVE
5/8"(15.9mm)
MFL

RELIEF VALVE
5/8"(15.9mm)
MFL
FACTORY-INSTALLED FLOW
SWITCH LOCATED IN PIPE
ON INLET WATER CONNECTION

RELIEF VALVE
3/8" (9.5mm)
SAE MFL

Page 6

244 mm

252 mm

VICTAULIC WATER
CONNECTION (INLET)

VICTAULIC WATER
CONNECTION (OUTLET)

26 mm

1120 mm

END VIEW

2240 mm

2188 mm

2375 mm

152 mm

Page 7

CONTROL PANEL

ISOMETRIC VIEW

LOCATE CUSTOMER POWER CONNECTION HERE.

APPROXIMATELY 102 mm - 330 mm
FROM BOTTOM OF UNIT BASE AND 25 mm 254 mm FROM FRONT OF CONTROL PANEL.

(4X) LIFTING PLATE

Page 8

2 23 5 mm

W1 NE AR S IDE
W2 FA R S IDE

SIDE VIEW

CG

TOP (PLAN) VIEW

NO OBSTR UCTIONS REC OM MEND ED.

AREA REQU IR ED FOR U NIT OPER ATION,
MAINTENAN CE, ACCE SS PAN EL AND A IR
FL OW.

1 2 19 m m

23 88 mm

W3 NEA R S IDE
W4 FA R SI DE

61 0 mm

TUBE REMOVAL
CL EARAN CE AREA.
(NON C ON TROL PANEL
END )

N O OB STRU C TION S ABOVE TH E CON D ENS ER

1 21 9 mm

WORKIN G CL EARAN CE PER N ATIONAL

EL ECTRIC C OD E ARTICLE 11 0-26 .

FOR OBSTRU CTION S OR M ULTIPLE UN ITS,

REFER TO TH E C LOSE SPACING BUL LETIN.
1 33 9.5 k g

1 1 89 .3 kg

12 76 .4 kg

11 08 .1 kg
4 91 3 k g

TOTAL
WEIGHT

90 2 mm

CON TR OL P ANEL

BACK VIEW

11 43 m m

CG

24 3 8 mm

ISOMET RIC VIEW

NOTES :
1. LIFTING C HAIN S/CAB LES W IL L N OT B E THE SA ME LEN GTH . AD JUS T TO
KEEP U NIT LE VEL W HIL E L IFTIN G.
2. DO N OT FOR K LIFT UN IT.
3. WEIGH TS ARE TYP IC AL FOR UN ITS W ITH R- 13 4A C HAR GE.
4. WEIGH TS ARE TYP IC AL FOR UN ITS W ITHOU T L OUV ER PA NEL S.

W4

W3

W2

LIFTING WEIGHTS

W1

Page 9

14 0 TON

UN IT
SIZE

14 0 TON

U NIT
SIZE

6 48 .6 kg

62 7.3 kg

10

UN IT TOP (PL AN ) VIEW

NOTE: Po in t lo ad s an d l oca tion s ar e pro vi de d for cu stom er u se o nly. NO ISOLA TORS AR E PR OVIDED WITH TH IS C HIL LER .

MAX
LOAD

50 56 kg

TOTAL
OPE RATIN G
WE IGH T

25 m m

N /A

1 34 6 mm

1 34 6 mm

11 68 mm

38 4 mm

MOUNTI NG LOCA TION 1 I S DI MENS IONED FROM

THE E DGE OF THE UNI T B AS E (NOT THE EDGE OF THE
CONTROL PA NE L)

N/A

10

C ONTR OL PAN EL

N /A

N /A

N/A

6 25 .5 kg

6 04 .6 kg

6 38 .7 kg

61 7.3 k g

10

MOUNTING LOCATIONS AND ISOLATOR PART NUMBER

NOTE: Po in t lo ad s an d l oca tion s ar e pro vi de d for cu stom er u se o nly. NO ISOLA TORS AR E PR OVIDED WITH TH IS C HIL LER .

6 57 .7 kg

6 35 .9 kg

MOUNTING LOCATIONS AND POINT LOAD WEIGHTS

1.

5 K14

5K1 5

1 K1 7

1K 16

13

CUSTOM ER SUPPL IED

1 15 V6 0HZ POWER o r
220 V5 0HZ FOR
PO WERSUPPLY FOR EVAPORATOR
HEATERAND/ORCOVENIENCE
OUTLET
(MAX FUSE SIZE:
15A FOR6 0HZ
20 AFOR 50HZ)

CP2 7

CP2 6

CP2 5

CP24

CP2 3

CP2 2

CP21

CP20

CAUTION-DO NOT ENERGIZETHEUNIT UNTIL CHECK OUT ANDSTARTUPPROCEDURES HAVE BEEN COMPLETED.

GENERAL NOTES:

4
10
15

OPEN= STOP

EMERGENCYSTOP
CLOSED= AUTO

EXTERNAL AUTO
STOP
CL OSED= AUTO
OPEN = STOP

CIRCUIT 2
EXTERNAL CIRCUIT
L OCKOUT SWITCH
OPEN = NORMAL
CLOSED= LOCKOUT

CIRCUIT 1
EXTERNAL CIRCUIT
LOCKOUT SWITCH
OPEN = NORMAL
CLOSED = LOCKOUT

1 TB4

CP27

CP2 6

CP25
CP2 4

CP23

CP22

CP21

CP20

2 J2

J2

1 U4
AUTO/EM ERGENCY
STOP

J1 1

J1

1 U5
EXTERNAL CIRCUIT
LOCKOUT

J1 1

J1

CP41

CP42

1 U1 0
CHIL LEDWATER
PUM PCONTROL
3

ON

AU TO

O FF

J2

5K 1- O L

CP41
CP4 2

5K 1

3 10 15 18
CUSTOM ER SUPPL IED
1 15 V6 0HZ O R2 20 V50 HZ
POWERFOR CHIL LED WATER PUMP
CONTROL
(MAXIM UM FUSESIZE 15 A)

20

5K1 A U X

18

17

16

15

14

13

12

11

10

1TB6

1TB6

24

5K1

5B 1

SINGL ESOURCE
POWER OR
DUAL SOURCEPOWER
FOR CIRCUIT 1

FAI LURE TO DO THE ABOVE

BE FORE SE RVICING COULD RESULT
I N DEATH OR SE RIOUS INJURY.

WARNING
DISCONNECT ALL ELE CTRI C P OWER
I NCLUDING REMOTE DISCONNE CTS
AND FOLLOW LOCK OUT AND TAG
PROCEDURES BE FORE SERVICING.
I NSURE THAT ALL MOTOR
CAPACITORS HAVE DIS CHARGED
STORE D VOLTAGE. UNI TS WITH
VA RIA BLE SPEE D DRI VE, REFER
TO DRIV E INSTRUCTIONS FOR
CAPACITOR DISCHARGE .

FAILURE TO DO SO MAY CAUSE DAMAGE TO THE

EQUI PMENT.

UNIT TERMINALS ARE NOT DESI GNED TO ACCEPT

OTHER TYPES OF CONDUCTORS.

L1
L1

4
10
11
19

W1
W2

CA UTION
US E COPP ER CONDUCTORS ONLY!

SINGL ESOURCE OR
DUAL SOURCECIRCUIT 1
POWER

FIELD WIRIN G P AGE 1 OF 2

1CB1
or
1 TB1
or
1SW1

L3
L3

CUSTOMERSUPPL IED
CL ASS 2 CONTROL WIRING

11 5V CUSTOMER SUPPLIED
CONTROL WIRING

L2
L2

(U S E 6 KN O CK O UT S IN RE AR OF P AN E L)

( U SE 6 K N OC K OU TS IN F RO N T O F PA NE L)

J1

J1 1

Page 10

24 V

1 T B4
1
2
3
4

FIE LD WIR IN G PAGE 2 OF 2

P OWER WIRE S ELEC TION TO CIRC U IT BR EAKE R (1 CB1 )

UN IT SIZE

CU STO MER SUPPLI ED

1 15 V 60 HZ POW ER o r
50 HZ FO R

10 00 0.00 A

LU G WIR E SIZE R AN GE (PER PHA SE) 2 20V

14 0

UN IT VOL TAGE

SH ORT C IR C UIT WITH STAN D R ATIN G

C U STOMER WIR E SEL ECTION TAB LE

46 0A

POWER SUPPLY FO R EVAPOR ATO R

H EATER AND/O R CO VENIENC E
O UT LET
( MAX F USE SIZ E:
1 5A FO R 6 0HZ
2 0A F OR 50 HZ )
AWG-25 0M CM

C IRC 1 & 2 (S NGL P T PWR )

(1 ) 1 AWG-6 00 MCM OR (2) 1

GENERAL NO TES:
1.

C AUT ION- DO NOT ENER GIZ E T HE UN IT UNT IL CHECK OUT AND ST AR TU P PROC EDURES H AVE BEEN CO MPL ET ED.

2.

AL L MO TO RS ARE PR OT ECT ED F RO M PR IMARY SINGL E PHASE F AIL URES.

C AUT ION- T RANE PUM P CO NT ROL M UST BE USED TO PRO VIDE PUM P CO NT ROL . EVAPO RATO R C HILL ED W ATER
PU MP M UST BE C ONT RO LLED BY T HE CH ILL ER OU TPU T. F AILUR E T O CO MPL Y WI TH TH IS REQ UIREM ENT
M AY RESUL T IN D AMAG E T O T HE U NIT .

T HE F O LLO WIN G F EAT URES ARE OPT ION AL AND MAY OR M AY NO T BE PRO VI DED. C UST OM ER PRO VIDED W IRIN G F OR ALL ST ANDARD
FEAT UR ES AND O PT IONS IS SHO WN O N T HIS DIAGR AM . OPT IONAL F EATU RES ARE SO NO T ED .
L OW VOL TAG E OPT IO NS ( CLASS 2 )
T RACER COM M UNICAT IO N INT ERF ACE O R O TH ER BUIL DING AUT OM AT ION SYSTEM CO MM UNI CATI ON I NT ERFAC E
IC E MAKIN G ST ART /ST OP
EXT ERNAL CUREN T LIM IT AND EXT ERNAL CHI LL ED WAT ER SET PO INT
1 15 VOL T OPT ION S F OR 6 0HZ U NIT S OR 22 0 VO LT O PTIO NS F OR 50 HZ UNIT S.
IC E MAKIN G ST AT US
UN IT OPERAT ING ST AT US M ODUL E
EVAPO RATO R H EATER (F REEZ E PROT ECT IO N). ST ANDARD WIT H U NIT M OUN TED EVAPORAT O R. NO T USED W IT H REM OT E EVAPO RAT OR O PT ION.
L INE VO LT AGE OPT IONS
UN IT MO UNT ED T ERM INAL BLO CK, D ISCON NECT SWIT CH OR HACR C IRCUI T BREAKER ( TB, SW O R CB)

W IRIN G REQ UIREM ENT S

6.

R ECOM MEN DED F IELD WIR ING CON NECT IONS ARE SHO WN BY DOT T ED L INES

7.

AL L FIEL D W IRING M UST BE IN AC COR DANCE W IT H T HE NAT IO NAL ELECT RIC COD E AND ST AT E AND LO CAL R EQUIR EMENT S. EXPO RT UNIT
W IRIN G M UST CO MPL Y WIT H L OC AL APPL ICABLE CODES.

PO WER FO R T HE EVAPO RAT OR HEATER AND/O R O PTI ONAL CO NVENIENCE OUT LET I S SUPPLI ED BY A CO MM ON CUST OM ER PR OVIDED POW ER
SU PPLY. W HEN PO WERED , T HE HEAT T APE W ILL USE 1 64 0 VA O F T HE T OT AL AVAI LABLE SUPPLY O N 6 0 H Z U NIT S AND APPROXIM ATEL Y
1 39 0 VA ON 5 0 HZ UNIT S. EVAPO RAT OR HEATER S ARE NO T PROVI DED W IT H REM OT E EVAPOR ATO R UN IT S.

10

11

AL L CUST OM ER CO NT ROL CIR CUIT W IRING MU ST BE COPPER CON DUCT OR S ON LY AND HAVE A M INIM UM INSUL AT ION RAT ING OF 30 0 VO LT S.
EXCEPT AS NOT ED AL L C UST OM ER WI RING CON NECT ION S ARE M ADE T O CIRCU IT BOARD MO UNT ED BO X LUG S WI TH A WI RE RANG E OF 1 4 T O
1 8 AWG. T HE HEAT T APE AND/ OR C ONVEN IENCE O UT LET AND TH E GRO UND SIDE O F TH E FL OW SWIT CH GO T O T ERM INAL ST RIPS W ITH A
# 10 SET SCREW WH ICH W ILL ACCEPT R ING OR F O RK T ERMI NALS O R ST RIPPED WIR E LEADS.
D O NO T RUN LO W VO LT AGE C ONT RO L W IRIN G ( 30 VOL TS OR L ESS) I N CO NDUIT W IT H 1 10 VOL T OR H IGHER WIR ING. DO NOT EXCEED TH E
F O LLO WIN G M AXIMU M R UN L ENGT HS FO R A G IVEN SIZ E: 1 4 AWG, 50 00 FT ; 16 AWG , 2 000 F T; 18 AWG , 1 00 0 F T .

13

T HE CONT ACT S F OR T HESE F EATU RES ARE J UMPERED AT T HE F ACT ORY BY J UMPER S W1 & W 2 T O ENABLE U NIT OPER ATIO N. IF REMO T E
C ONT RO L IS DESIRED REMO VE T HE JU MPERS AN D CO NNECT T O TH E DESIRED CON TR OL CIRC UIT .

14

AS SHIPPED T HE N ORM AL 400 VOL T UNIT C ONT RO L PO WER TR ANSFO RM ERS ARE W IRED ON T HE 400 VO LT T AP (H 3). T RANSF ORM ER L EADS
1 26 A & 1 26B SHOU LD BE RECON NECT ED T O TH E APPROPRI ATE TAP F O R T HE 3 80 (H2 ) O R 4 15 (H 4) VOL T PO WER SUPPLIES.

15

G RO UND AL L C UST OM ER PRO VIDED 1 15 VOL T POW ER SUPPL IES AS REQ UIRED BY COD ES. GR EEN GR OUN D SCREW S ARE PR OVIDED IN T HE
U NIT CO NT ROL PANEL.

C ONT ACT RAT ING S AND REQU IREMEN TS:

18

UNIT PR OVIDED DRY CO NT ACT S F OR THE EVAPORAT OR PUM P CON TR OL, T HE UNI T OPERAT ING ST ATU S RELAYS & TH E ICE M AKING ST ATU S RELAY
(1 U10 , 1 U12 , & 1 U1 3) ARE RAT ED F OR 7. 2 AM PS RESIST IVE, 2.8 8 AM PS PIL OT DUT Y, OR 1 /3 HP, 7 .2 FL A AT 12 0 VOLT S 6 0 H Z. CON TAC TS
ARE RAT ED F OR 5 AM PS GEN ERAL PU RPOSE D UT Y AT 240 VO LT S. T HE M AX F USE SIZ E F OR ANY OF T HESE C IRCUIT S I S 15 AMPS.

19

C UST OM ER SUPPL IED CO NT ACT S F OR AL L L OW VOL T AGE CO NNECT IO NS M UST BE CO MPAT ABLE WIT H D RY CIR CUIT 2 4 VO LT S DC FO R A 1 2
M A RESI ST IVE LOAD . SIL VER OR GO LD PLAT ED CO NT ACT S ARE R EC OM MEN DED.

20

F L OW SWIT CH AND IN TERL OC K CON TAC TS M UST BE AC CEPT ABL E F OR USE IN A 24 VOL T 12 mA CIRCU IT. REM OVE JU MPER BETW EEN
1 T B6-5 AND 1T B6- 3 W HEN 5K1 AUX CO NTAC T IS USED.

24

T HE F UN CTI ONS O F T HE OPER ATIN G ST AT US M ODU LE REL AYS ARE PR OGR AMABL E. DEF AULT F UN CTI ONS AR E SHOW N. SEE IOM F OR DET AILS.

Page 11

G enera l
Uni ts a re l e ak an d p ressure te sted at 39 0 p si g (26 8 9 kPa ) h i gh sid e , 2 50 psi g (1 72 4 kP a) l ow si d e, the n e va cua ted an d
cha rge d . A ll A ir-coo l ed Se rie s R(TM ) ch il l e rs a re factory te ste d to co nfi rm o pe rati on pri o r to sh i pm en t. P ackag ed un i ts shi p
wi th ful l op era tin g ch arg e o f o i l a nd refri ge ran t.
Uni t pa n el s, structura l e l em en ts a nd co n tro l b o xe s a re co nstru cted of ga l va n ize d stee l a n d mo u nte d o n a we ld e d stru ctu ral
stee l ba se . Un it p an el s an d co ntrol b oxes a re fin i she d with a b ake d-o n p owde r pa i nt, an d th e stru ctu ral b ase wi th an ai r dry
p ai n t. A ll p ai n t m ee ts the req ui re me nt for ou tdo o r e qu i pm en t of the U.S . Navy a n d o th e r Fed e ra l Go ve rnm en t Ag en cie s
a nd me ets AS TM B1 17 50 0 h ou rs sa l t spra y fo g te st.
A nyti me wa te r on l y i s p rese nt i n the eva po rato r, th e Tra ne CH5 30 mu st ha ve fl ow co n tro l o f th e ch il l e d wate r syste m. Fl ow
con trol can be do ne ei th er di re ctl y o r th rou gh an i np ut to a bu i ld i ng au tom ati o n syste m to con du ct a n a cti o n re su l tin g i n
m in i mu m fl ow th rou g h the ch i l le r evap o ra tor b arrel to a voi d p o te n ti a l ly ca tastrop h ic da ma g e to th e e va p ora to r du e to
free zin g . If th e syste m h as su ffici e nt gl yco l to pro tect do wn to the lo west expe cte d a mb i en t, fl o w con tro l is o pti on a l.
E v a porator
T he eva po rato r i s a tub e -i n -sh el l he a t e xch an g er de si gn wi th i nte rna l ly a nd extern al l y fi nn e d cop p er tub es rol l er e xp a nd ed
i n to the tu b e she e t. Th e e vap ora tor i s d esi gn e d, tested an d stam pe d i n accord an ce wi th A SM E P ressure V e sse l Cod e
S ecti on VIII fo r a refri ge ran t si de wo rkin g p ressure of 20 0 p si g (13 7 9 kPa ). T he evap o ra tor i s d e si g ne d fo r a wa ter sid e
worki ng pre ssu re o f 1 50 psi g (1 03 4 kP a). Wate r co nn ecti on s a re g roo ve d p i pe . Ea ch she l l i n cl u de s a ve n t, a d rai n an d
fi tti n gs for tem pe ratu re con tro l se n so rs a nd i s i n su l ate d with UV re sista nt 0.7 5 i n ch Arma fl ex II o r e qu a l i n su l ati o n (K=0.2 8).
In su l ati o n a lso co ve rs th e l i qu i d a nd su ctio n l i n e a nd evap o ra tor h ea ds. He ate rs, with th e rm ostat, are pro vi d ed to h el p
p rote ct the eva po rato r from fre ezi ng at a mb ie n t te mp era tu res d own to -2 0 F (-2 9 C), d ep en d in g o n a p pl i ca ti on .
Note : A se pa rate fi e l d sup p li e d l o w vol tag e p o we r so urce i s re qu i red to po wer the fre eze p rote cti o n.

O pe rating Te mpe ra ture

B razed pl a te refri ge ran t co ol e d o i l co ol e rs are pro vi d ed on the un i t, a ll o wi n g o pe rati on i n l ow tem pe ratu re eva po rato r, l ess
th an 40 F (4 C), m od es.
Chilled Wa ter Re se t
P rovi de s th e con trol l og i c a nd fa ctory-i n sta l l ed se nso rs to re se t le a vi n g chi l l ed wa ter tem pe ratu re. Th e setp oi n t ca n b e
re se t ba se d o n a mb i en t te mp e ra ture or retu rn eva po rato r wate r te mp era ture .
P re s sure V es se l Code
Chi l l er com pl i es wi th A S ME P ressure V e sse l Cod e S e cti on VIII. A SM E n am ep l ate s a re a tta che d to a p pl i ca b le pre ssu re
vesse ls i ncl ud i ng oi l se p ara to rs.
Condense r a nd Fans
A i r-coo l ed co n de nse r co il s ha ve l an ced al u mi n um fi n s me cha n ica ll y bo nd e d to i n te rna l l y fi nn e d cop pe r tu b es. T he
con d en ser co i l h a s a n i n te g ra l su b co ol i n g circu it. Co nd en sers are fa cto ry p roo f a n d l ea k te sted at 50 6 p sig (34 89 kPa ).
Di re ct d rive ve rti cal d ischa rge co n de nse r fa ns a re dyn am ica ll y ba l an ced . T hre e p ha se con d en se r fa n m oto rs wi th
p erm an en tl y l ub ri ca ted ba l l b e ari ng an d i n tern al the rma l p rote cti on are pro vi d ed . S tan da rd u ni ts wi l l start an d o p era te
d own to 25 F (-4 C) a mb ie n t, a nd up to 11 5 F (46 C) am bi e nt.
T ota l ly En clo sed Ai r-Over (TE AO ) m oto rs com pl e tel y se al mo tor win d in g s, p re ven tin g e xpo sure to we ath er con di ti on s.
T EA O fan mo tor i nsu la ti on cl a ss F.
Uni t i s a lso de sig n ed to sta rt a nd op e ra te i n h i gh am bi e nt con d iti o ns; u p to 12 5 d eg ree s F.
Com pre ss or S ta rte r - Y de lta

Page 12

S tarter i s a wye-d el ta cl o se d tran si ti o n con fi gu rati on . T h e wye -de l ta cl o sed tra nsi ti on sta rte r re du ces i nru sh cu rren t (L ocked
Roto r A mp s) b y 6 6% . T he sta rter i s facto ry mo un ted an d co mp le tel y pre wi red to the com pre sso r m oto r. Sta rte rs a re h ou sed
i n a we a th e rti g ht en clo sure pe r UL 1 99 5 .
Com pre ss or a nd Lube Oil Syste m
T he rota ry scre w com pre sso r i s se mi -h erme ti c, di re ct dri ve, 3 60 0 rp m, wi th step an d vari a bl e l o ad an d u n lo a de r va l ve s fo r
cap a ci ty co ntrol , rol l i ng el e me nt be a ri n gs, di ffere nti a l re fri g era nt pre ssu re o il p um p a nd oi l he ate r. T he mo to r is a su cti o n
g as coo l ed , h e rm eti cal l y se al e d, two po l e squ i rre l ca ge i nd ucti on mo to r.
O il sep a ra ti on is p ro vid e d sep a ra te from th e co mp re sso r. A uto ma tica ll y co n tro l le d va lve s a re p ro vi de d o n th e com pre sso r
d i sch arg e a nd lu b e o il syste m. A so l en o id va l ve i n th e l ub e o i l re turn syste m i s a l so p ro vid e d. Oi l fi l tra ti on is
a cco mp l ish ed by an i nte gra l o i l fi l te r lo cate d with i n the co mp ressor.
Refrige rant Circ uits
E ach u n it h as two re fri g era nt ci rcu its, wi th o ne or two ro tary screw co mp resso r p er circui t. E a ch re frig e ra n t ci rcu i t i n cl u de s
com pre sso r su cti o n a nd di scha rge se rvi ce val ve s, l iq u id l in e sh uto ff val ve (e xce pt rem ote e vap ), re mo va b le co re fi l te r,
l i qu i d l i ne sig h t g l ass, cha rgi n g p ort an d o n e e le ctro n ic exp an sio n va lve pe r ci rcu i t. Fu l l y m od ul a tin g co mp re sso rs a n d
e l ectro n ic e xp an si on va l ve s p rovi de vari ab l e cap a ci ty m od u la ti on over the en ti re op e ra ti ng ra n ge .
Unit Controls
A l l u ni t co n tro l s a re h ou se d i n a o utd oo r ra ted en clo sure p e r UL 1 99 5 wi th rem ova bl e p l ate s to al l ow fo r cu sto me r
con n ecti on of po we r wi ri ng an d re mo te i nte rl o cks. A l l co ntrol s, i n clu d in g se nso rs, are fa cto ry m ou nte d a nd tested pri o r to
sh ip me n t.
M icroco mp ute r co ntrol s pro vi d e a l l con trol fun cti o ns i ncl ud i ng sta rt u p a nd shu tdo wn , le a vi n g chi l l ed wa ter tem pe ratu re
con trol , co mp ressor a nd el e ctron i c e xpa nsi o n val ve mo d ul a ti o n, fan seq ue n ci n g, an ti -re cycl e l og i c, a uto ma tic l ea d/l a g
com pre sso r sta rti n g, l oa d l i mi ti ng an d ch il l e d wa ter p um p con trol .
T he un i t co ntrol mo d ul e wi th Ra p id Re start (T M), uti l izi n g Ad a pti ve Co n tro l (T M) mi cro p ro cessor a uto ma ti cal l y ta kes acti on
to a voi d u n it shu tdo wn d ue to ab n orma l op era tin g co nd i ti o ns a sso ci a te d wi th l ow refri ge ran t p ressure , h i gh co n de nsi n g
p ressure a n d mo tor curre nt ove rl o ad . S h ou l d the ab n orma l op era tin g co nd i ti o n con ti nu e u nti l a p ro tecti ve l im i t i s
vi ol a te d , th e u ni t wi l l b e sh ut d own.
A co ntro l p owe r tran sfo rme r i s factory in sta l l ed an d wi re d .
Controls Func tion Data
Uni t pro tective fu ncti on s i n clu d e l oss of ch i l le d wa te r fl o w, e va po rato r fre ezi ng , l o ss o f re fri g era nt, l ow re fri g era nt p re ssure ,
h i gh re frig e ra n t p ressure , co mp re sso r sta rti n g a nd run ni n g o ve r cu rre n t, p ha se l oss, p h ase i m ba l an ce , ph ase re versal ,
u nd e r/o ve r vo l tag e p rote cti on an d l o ss o f o i l fl ow.
A me nu dri ve n d i gi ta l d i sp l ay i nd i ca tes ove r 2 0 o pe rati n g d ata p o in ts i n cl u di n g ch il l e d wa ter set p oi n t, curren t li m it set
p oi n t, e nte rin g a n d l ea vin g ch i ll e d wate r te mp era tu re, e va p ora to r an d con d en ser refri ge ran t p ressure s a n d tem pe ratu res.
O ve r 60 di a gn osti c che cks a re ma de an d d i sp l aye d whe n a pro bl e m i s d ete cte d. Th e d i gi ta l d i sp l ay ca n b e re ad an d
a dva nce d o n the un i t wi th o ut op e ni n g a ny co n tro l p a ne l d o ors. T ou ch scre e n L CD, a l lo ws for e asy a cce ss o f a l l i m po rta n t
chi l l er o pe rati ng i nfo rm ati o n.
S hort Circ uit Current Rating (SCCR)
A sh ort circui t cu rren t ra tin g o ffers a me a su re o f sa fe ty fo r wha t th e sta rte r p a ne l e n cl o su re i s ab l e to with sta n d i n th e e ve nt
o f a n e xpl o si o n cau sed by a sh ort ci rcui t.
Circ uit Bre ak e r
A sta nd ard in terru pti ng mo l de d ca se ci rcui t bre ake r i s p rovi d ed wi th thro ug h -th e-d oo r lo cka b le ha n dl e to di sco n ne ct th e
m ai n p o we r a n d com es pre -wi red fro m the factory wi th te rm i na l b l ock po we r co nn e cti on s.
P ow er Conne ction

Page 13

Uni t i s p ro vi de d with si n gl e -po i nt el e ctri cal po we r co n ne cti o n. Fi e l d wiri n g con ne cti o n p oi n t wi l l b e o n th e b ottom ri g ht
corn er o f th e e le ctri cal p an el .
Flow S w itc h
T he re i s a factory in stal l ed flo w switch wi th a vel o ci ty se tpo i nt of 6 0 cm/sec i ncl ud ed on thi s ch i ll e r.
Warranty
A Fi rst Y ea r P a rts Wa rra nty i s i ncl u de d, coveri n g the wh o le un i t. T he wa rra nty i s val i d fo r 1 2 m on ths afte r start-up or 1 8
m on ths afte r shi p me nt.

Page 14

RTAC140 Standard Tag: RTAC140 STD

Part Load Performance
NPLV = 13.7
% Load
100
75
50
25

Note:

Capacity
122.3
91.7
61.2
30.6

LWT
45.0
45.0
45.0
45.0

EWT
55.0
52.5
50.0
47.5

Flow
292.4
292.4
292.4
292.4

WPD
8.5
8.6
8.6
8.6

Ambient
110.0
80.0
65.0
55.0

kW Efficiency
192.9
7.6
91.5
12.0
48.3
15.2
26.0
14.1

1.NP LV = 0.01A + 0.42B + 0.45C + 0.12D

Where: A = EER at 100% at user defined ambient temperature with 1% weighting
B = EER at 75% at user defined ambient temperature with 42% weighting
C = E ER at 50% at user defined ambient temperat ure with 45% weighting
D = E ER at 25% at user defined ambient temperat urewith 12% weighting

2. NPLV is defined using the input design conditions, outside of A HRI conditions at 100%
full load.
Part

3. NPLV and/or NPLV may not be reflective of local climate conditions. The Customized
Load Value Calculation may provide a more accurat e measure of part load efficiency.

Version: 174.0

abril 14, 2015

TRANE Air-Cooled Series R(TM) Chiller

Page 15