CS Series

50.4
4 CHANNEL POWER AMPLIFIER

SERVICE MANUAL

JBL Consumer Products

250 Crossways Park Dr.
Woodbury, New York 11797

Rev0 3/2004

CS Series 200.1

- CONTENTS -

SPECIFICATIONS ...1
CONNECTIONS...........2
CONTROLS .............3
BASIC TROUBLESHOOTING....3
EXPLODED VIEW/PARTS LIST.......4
AMPLIFIER BLOCK DIAGRAM.5
P.C.B. DRAWINGS...6
ELECTRICAL PARTS LIST .....10
IC/TRANSISTOR PINOUTS..........13
SCHEMATICS.....14
PACKING........19

CS50.4 Specifications
Output Power:
(14.4V supply)

67W RMS x 4 channels @ 4 ohms; 1% THD + N

82W RMS x 4 channels @ 2 ohms; 1% THD + N
162W RMS x 2 channels @ 4 ohms; 1% THD + N

Signal-to-noise ratio:

86dBA (reference 1W into 4 ohms)

Dynamic power:

145W @ 2 ohms

Effective damping factor:

6.395 @ 4 ohms

Frequency response:

10Hz 27kHz (3dB)

Maximum input signal:

6V

Maximum sensitivity:

240mV

Bass boost (45Hz)

Variable 0 6dB

DC Offset

<30mV

Output regulation:

.032dB @ 4 ohms

Idle Current

0.65A

Input Impedance

20k

Max Current Draw

26A @ 4 ohms
49A @ 2 ohms

Dimensions:

12 x 10 x 2 1/4 (L x W x H)
(305mm x 254mm x 57mm)

Fuses:

25A x 2

JBL continually strives to update and improve existing products, as well as create new ones. The specifications and
details in this and related JBL publications are therefore subject to change without notice.

CS Series 50.4

APPLICATIONS CS200.1
The CS subwoofer amplifier is a
single-channel amplifier. There are
two sets of terminals to make it easy
to connect multiple woofers. Either
set of (+/) terminals may be used
when connecting woofers.
To the right are two application
diagrams to help plan your subwoofer
system installation. Figures 2 and 3
show how to configure the CS200.1
subwoofer amplifier.
NOTE: For simplicity, Figures 2 and 3
do not show power, remote and input
connections.
NOTE: Minimum speaker load is
2 ohms total.

Figure 2. CS subwoofer amplifier with two woofers

connected.

Figure 3. CS subwoofer amplifier with one woofer

connected.

APPLICATIONS CS50.4
The CS50.4 can be set up for stereo
4-channel, 3-channel or bridged
2-channel operation, as shown in
Figures 4 through 6.

NOTE: For simplicity, Figures 4 through

6 do not show power, remote and input
connections.

Figure 4. CS50.4 amplifier in 4-channel (stereo)

operation to drive front and rear full-range speakers.

NOTE: Minimum speaker impedance

for stereo operation is 2 ohms.
Minimum speaker impedance for
bridged operation is 4 ohms.

Figure 5. CS50.4 is set up for 3-channel operation to

drive a set of full-range speakers and a subwoofer.

Figure 6. CS50.4 used in bridged 2-channel mode

to drive a set of components or subwoofers. Set
crossovers according to application.

CS Series 50.4

CONTROLS AND SETUP

SETTING THE
CROSSOVER(S)
Determine your system plans and set
the crossover mode switch accordingly.
If your system design does not include
a subwoofer with the CS50.4, set the
crossover mode to FLAT and skip to
Setting Input Sensitivity.
Initially set the crossover frequency
control midway. While listening to music,
adjust the crossover for the least
perceived distortion from the speakers,
allowing them to reproduce as much
bass as possible.

SETTING INPUT
SENSITIVITY
1. Initially turn the INPUT LEVEL control(s)
to minimum (counter clockwise).
2. Reconnect the () negative lead to the
vehicles battery. Apply power to the
audio system and play a dynamic music
track.
3. On the source unit, increase the volume
control to 3/4 volume. Slowly increase
the INPUT LEVEL control(s) toward three
oclock until you hear slight distortion
in the music. Then reduce the INPUT
LEVEL slightly until distortion is no
longer heard.

Systems using a separate subwoofer set

the crossover mode to HP (high pass) for
your full-range speakers. Adjust the
crossover frequency to limit bass and
provide increased system volume with
less distortion.

NOTE: After the source unit is on, blue

LEDs (on the top panel) will light, indicating
the amplifier is on. If not, check the wiring,
especially the remote connection from the
source unit. Also refer to Troubleshooting
guide below.

For subwoofers, choose the highest

frequency that removes vocal information
from the sound of the subwoofer.
If using the CS50.4 to drive a subwoofer(s),
set the crossover mode to LP (low pass).

TROUBLESHOOTING
SYMPTOM
No audio
(POWER LEDs
are off)
No audio
(POWER
LEDs are on)

LIKELY CAUSE
No voltage at BATT+
or REM terminals,
connection
or bad or no ground
Amplifier is
overheated

Voltage more than 16V

or less than 8.5V on
BATT+ connection

SOLUTION
Check voltages at
amplifier terminals
with VOM
Make sure amplifier
cooling is not blocked
at mounting location;
verify speaker-system
impedance is within
specified limits
Check vehicle
charging system

SYMPTOM
No audio
(POWER
LEDs flash)

Distorted audio

Distorted audio
and POWER
LEDs flash
Music lacks
punch

Features, specifications and appearance are subject to change without notice.

LIKELY CAUSE
Voltage less than 9V on
BATT+ connection

SOLUTION
Check vehicle
charging system

DC voltage on
amplifier output

Amplifier may need

service; see enclosed
warranty card for
service information
Check INPUT
LEVEL setting; or
check speaker wires
for shorts or grounds
Remove speaker leads
one at a time to locate
shorted speaker or
wire, then repair
Check speaker
connections for
proper polarity

Input sensitivity is
not set properly, or
amplifier or source
unit is defective
Short circuit in
speaker or wire

Speakers are not

connected properly

CS Series 50.4

Block Diagram

INPUT
FRONT L

CS50.4

CS Series 50.4

MODE HP/FLAT/LP
VARIABLE LPF/HPF

BALANCED
INPUT
(UNIT GAIN)

BOOST
VARIABLE
0dB--6dB/45Hz

32Hz--320Hz/12dB

10 320
Ap

AUX OUT
FRONT L+ REAR L

20K

10 50

Ap

20K

MAIN AMP
FRONT L

2 ohm/4 ohm
D

Ao

SPEAKER

Ap
Ap
Ap
MODE HP/FLAT/LP

INPUT
REAR L

BALANCED
INPUT
(UNIT GAIN)

BOOST
VARIABLE
0dB--6dB/45Hz

VARIABLE LPF/HPF
32Hz--320Hz/12dB

10 320

20K

10 50

Ap

Ap

20K

INPUT
FRONT R

VARIABLE LPF/HPF

10 320

20K

10 50

Ap

AUX OUT
FRONT R+ REAR R

VARIABLE
0dB--6dB/45Hz

32Hz--320Hz/12dB

Ap

REAR L

2 ohm/4 ohm
C

Ao

SPEAKER

MAIN AMP

MODE HP/FLAT/LP
BALANCED
INPUT
(UNIT GAIN)

MAIN AMP

20K

FRONT R

2 ohm/4 ohm

Ao

SPEAKER
B

Ap
Ap
Ap
MODE HP/FLAT/LP

INPUT
REAR R

BALANCED
INPUT
(UNIT GAIN)

VARIABLE LPF/HPF
32Hz--320Hz/12dB

10 320

20K

10 50

Ap

Ap

BOOST
VARIABLE
0dB--6dB/45Hz

20K

MAIN AMP
2 ohm/4 ohm

REAR R

Ao

SPEAKER

CS Series 50.4

CS Series 50.4

CS Series 50.4

CS Series 50.4

CS Series 50.4

CS 50.4 Electrical Parts List

Part Number

Description

Qty Reference Designator

Main PCB
Semiconductors
124TN4401

Transistor

MOTOROLA 2N4401

21

124TN4403
124T0SA06
124T0SA56
125T0C945
127TB1238
127TD1859
129T0J109
131TN4148
133T0J5B6
133T0011B
133T0015B
134TN4002
154TTL431
151T04558
154T04558
154LM358N
158TTL494
134TN5402
123TRFZ4N
124TN6488
124TN6491
135T1620C
135T1620R

Transistor
Transistor
Transistor
Transistor
Transistor
Transistor
Transistor
Diode
Diode
Diode
Diode
Diode
IC DIP3
IC SIP8
IC DIP8
IC DIP8
IC DIP16
Diode
Transistor
Transistor
Transistor
Diode
Diode

MOTOROLA 2N4403
MOTOROLAMPSA06 80V
MOTOROLAMPSA56 80V
NEC 2SC945P 0.1A60V
B1238
D1859
J109
DIODE NS1N4148HSS150MA
DIODENECRD5.6JSB ZNR5.6V
DIODE NEC RD11EB3 11V
DIODE NEC RD15EB3 15V
DIODE 1N4002 RET1.0A100V
TL431
JRC MC4558
ROHM BA4558
CHINALM358N
NEC UPC494 OR TI TL494
DIODE 1N5402 ET3.0A100V
IR IRFZ46N
TR MOTOROLA 2N6488 80V
TR MOTOROLA 2N6491 80V
DIODE MOTOROLA 1620CT
DIODE MOTOROLA 1620CTR

11
4
4
4
6
5
1
13
1
1
2
8
1
1
6
1
1
1
4
4
4
1
1

220220220
22022047A
220220470
220440100
220440101
220440103
220440272

Resistor
Resistor
Resistor
Resistor
Resistor
Resistor
Resistor

RD 1/2W 22
RD 1/2W 4.7
RD 1/2W 47
RD 1/4W 10
RD 1/4W 100
RD 1/4W 10K
RD 1/4W 2.7K

1
4
2
1
4
4
4

220880000

Resistor

RD 1/8W 0

25

220880101

Resistor

RD 1/8W 100

18

220880102

Resistor

RD 1/8W 1K

19

220880103
220880104
220880123
220880153
220880154
220880183
220880202
220880204
220880205
220880221L
220880222
220880223
220880242
220880243
220880272

Resistor
Resistor
Resistor
Resistor
Resistor
Resistor
Resistor
Resistor
Resistor
Resistor
Resistor
Resistor
Resistor
Resistor
Resistor

RD 1/8W 10K
RD 1/8W 100K
RD 1/8W 12K
RD 1/8W 15K
RD 1/8W 150K
RD 1/8W 18K
RD 1/8W 2K
RD 1/8W 200K
RD 1/8W 2M
RD 1/8W 220 52mm
RD 1/8W 2.2K
RD 1/8W 22K
RD 1/8W 2.4K
RD 1/8W 24K
RD 1/8W 2.7K

11
8
1
2
2
9
6
1
1
4
1
2
4
2
1

Q2,4,5,16,17,Q138,238,338,438,Q140,240,340,440,Q135,
235,335,435,R143,243,343,443
Q6,9,10,Q136,2326,336,436,Q137,237,337,437
Q145,245,345,445
Q139,239,339,439
Q144,244,344,444
Q7,Q8,Q146,246,346,446
Q14,Q141,241,341,441
Q1
D1~7,D11~16
ZD1
ZD2
ZD4 ZD3
D135,235,335,435,D136,236,336,436
Q3
IC202
IC101,201,301,401 IC102 IC302
IC2
IC1
D9
Q11~13,Q15
Q142,242,342,442
Q147,247,347,447
D8
D10

Resistors

10

R37
R152,252,352,452
R33 R32
R31
R25 R26 R28 R29
R154,254,354,454
R151,251,351,451
JP1 JP18 JP24 JP30 JP41~51 JP53 JP35~39 JP86
JP101~103
R27,R138,238,338,438 R139,239,339,439
R142,242,342,442 R143,243,343,443 R11
R7 R14-15 R137,237,337,437 R156,256,356,456
R157,257,357,457 R136,236,336,436
R135,235,335,435 R10 R20 R19 R108,208,308,408
R2~R6 R124 R224 R12
R17
R49 R50
R43 R42
R140,240,340,440 R141,241,341,441 R35
R40 R41 R144,244,344,444
R23
R22
R148,248,348,448
R36
R45 R30
R147,247,347,447
R123 R223
R24

CS Series 50.4
Part Number
220880302
220880363
220880392
220880470
220880472
220880473
220880474
220880562
220880563
220880682
220880751
220880821
220880913
230881001
230881002
230881003
230881052
230882202
230884751
230884991
207T15B24
232XL502J
261T05103

Description

Qty Reference Designator

Resistor
Resistor
Resistor
Resistor
Resistor
Resistor
Resistor
Resistor
Resistor
Resistor
Resistor
Resistor
Resistor
Resistor
Resistor
Resistor
Resistor
Resistor
Resistor
Resistor
VR
Resistor
Thermistor

RD 1/8W 3K
RD 1/8W 36K
RD 1/8W 3.9K
RD 1/8W 47
RD 1/8W 4.7K
RD 1/8W 47K
RD 1/8W 470K
RD 1/8W 5.6K
RD 1/8W 56K
RD 1/8W 6.8K
RD 1/8W 750
RD 1/8W 820
RD 1/8W 91K
MF 1/8W 1K 1%
MF 1/8W 10K 1%
MF 1/8W 100K 1%
MF 1/8W 10.5K 1%
MF 1/8W 22K 1%
MF 1/8W 4.75K 1%
MF 1/8W 4.99K 1%
WH9011A-2-18T B20K
SQM 5Ws 0.2
NTC THERMISTORD103J 10K

4
1
1
8
4
10
1
4
9
2
4
4
4
4
1
4
1
1
6
2
2
8
2

R39 R38 R18 R9

R51
R13
R145,245,345,445 R158,258,358,458
R146,246,346,446
R34 R101,201,301,401 R102,202,302,402 R1
R44
R155,255,355,455
R109,209,309,409 R110,210,310,410 R52
R46 R16
R111,211,311,411
R153,253,353,453
R100,200,300,400
R103,203,303,403
R48
R105,205,305,405
R47
R8
R213 R413 R112,212,312,412
R113 R313
VR101 VR201
R149,249,349,449 R150,250,350,450
RTH1 RTH2

31J510110
31K510210
31Z510305
31Z510410
31J522110

Capacitor
Capacitor
Capacitor
Capacitor
Capacitor

C/C NPO 100PF/100V J

C/C 1000PF/100V K
C/C Y5V 10000P/50V Z
C/C Y5V 0.1UF/100V Z
C/C NPO 220PF/100V

4
4
1
8
2

31J547010

Capacitor

C/C NPO 47PF/100V J

16

31K547310
31J568125
32J510410
32J568210
340Z10625
340Z10716
340Z10750
340Z22550
340Z22616
340Z22625
340Z47625
370Z10550
370Z10716
370Z22616
390Z22625
341T22835
341T10835

Capacitor
Capacitor
Capacitor
Capacitor
Capacitor
Capacitor
Capacitor
Capacitor
Capacitor
Capacitor
Capacitor
Capacitor
Capacitor
Capacitor
Capacitor
Capacitor
Capacitor

C/C 0.047UF/100V K
C/C Y5E 680P/250V K
M/C 0.1UF/100V J
M/C 0.0068uf/100V J
10UF/25V 5*11
100U/16V 5*11
100UF/50V 8*13
2.2UF/50V 5*11
22UF/16V
22UF/25V 5*11
47UF/25V 5*11
1UF/50V 5*11
100UF/16V 8*12
22UF/16V NP
22UF/25V 4*7
2200UF/35V 16*26 105C
1000UF/35V 13*26 105C

2
1
8
1
6
10
8
2
1
10
3
4
1
1
4
4
3

C101,201,301,401
C103,203,303,403
C35
C32 C31 C6 C7 C8 C9 C10 C11
C13 C12
C136,236,336,436 C142,242,342,442 C137,237,337,437
C105,205,305,405
C37 C38
C22
C143,243,343,443 C138,238,338,438
C20
C112 C212 C129,229,329,429
C19 C28 C27 C141,241,341,441 C4 C29 C30
C135,235,335,435 C140,240,340,440
C34 C33
C21
C2 C3 C100,200,300, C402 C104,204,304,404
C5 C36 C14
C139,239,339,439
C18
C1
C102,202,302,302 C400
C23 C24 C25 C26
C15 C16 C17

Wire
Wire
Coil
Transformer
Fuse
Fuse Holder
RCA Jack
Connector
Terminal
Terminal

1015# 20AWG 70MM

12Pin 60MM(CN*2)
T23*90-26 1.2*5 2.6uH
37 5:10 F=1.0*5 S=1.2*3
25A ATC
PCB Fuse Holder
RCA Jack
2Pin P=2.5MM 90
GA30-03-3P
EM-2304 4P*213.3

1
1
1
1
2
1
1
1
1
1

GND
J4
L1
T1
F1
F1
RCA1
J3
J1
J2

Capacitors

Miscellaneous

571T20070
572TB6012
172T41026
182T37510
435T00025
447T00001
526URDW14
535T25002
544T300003
544T34324

11

CS Series 50.4
Part Number

Description

Qty Reference Designator

Crossover PCB
220880000

Resistor

RD 1/8W 0

13

NP1~4 NP10 NP22 NP25 NP30 NP33-34 NP36-37 NP39

220880102

Resistor

RD 1/8W 1K

220880103

Resistor

RD 1/8W 10K

16

220880223
220880362
220880392
220880474
220880562
220880682
31J510110
31Z510410
31K547110
32J518410
32J539310
32J582310
340Z10716
154T04558
192R23D05
202G15B23
202T15C53
531T25012
137T05B02
647TCS504

Resistor
Resistor
Resistor
Resistor
Resistor
Resistor
Capacitor
Capacitor
Capacitor
Capacitor
Capacitor
Capacitor
Capacitor
IC DIP8
Switch
VR
VR
Connector
LED
Heat Sink

RD 1/8W 22K
RD 1/8W 3.6K
RD 1/8W 3.9K
RD 1/8W 470K
RD 1/8W 5.6K
RD 1/8W 6.8K
C/C NPO 100PF/100V J
C/C Y5V 0.1UF/100V Z
C/C Y5E470PF/100V K
M/C 0.18uf/100V J
M/C 0.039UF/100V J
M/C 0.082 UF/100V J
100U/16V 5*11
ROHM BA4558
SK-23D05 G=7 L1R3
B20K
C50K
12Pin P=2.5MM
5LED White
CS50.4 L=300

4
4
4
4
12
4
4
2
4
4
4
8
2
10
2
2
2
1
3
1

R119,219,319,419
R104,204,304,404 R106,206,306,406 R107,207,307,407
R114,214,314,414
R115,215,315,415
R120,220,320,420
R122,222,322,422
R125,225,325,425
R116,216,316,416 R117,217,317,417 R121,221,321,421
R118,218,318,418
C106,206,306,406
CN3 CN4
C11 C211,311,411
C109,209,309,409
C110,210,310,410
C107,207,307,407 C108,208,308,408
CN1 CN2
IC104,204,304,404 IC103 IC303 IC105,205,305,405
SW100 SW300
VR103 VR303
VR102 VR302
J5
BLED1~3

12

CS Series 50.4

Semiconductor Pinouts

13

CS Series 50.4

91K

R101
47K
C101
22u/50v
C102
22u/50v

101/C

R110

47K

R104

R102

IC101A
JRC4558
1 R103
1K

VR101A
C104

R109
56K

C103
102P

JRC4558
IC101B
7

56K
20K

R115
22K

R106

22u/50v

R112
15.2K

10K

101/C
B20K
VR102A

10K
R116
5.6K

IC105A
JRC4558

10K

10K
C105

1
320Hz

HIGH-1
B20K
VR102B

C107

X-OVER

2
R114

R105

R111
750

C106

X-OVER

823/M
6

32Hz

R117

5.6K

320Hz

823/M

SW100A

32Hz

1K
2P3T

JRC4558
IC104B

R119

FULL-1

IC105B
JRC4558

R118

C108

LOW-1

R107
10K

IC103B
JRC4558

5.6K

10P/C

Odb

R113
750

BASS TO 45HZ

C109
184/MET

RCA3O

R200

R123
24K

R201
47K
C201
22u/50v
C202
22u/50v

6
10U

101/C

R210

47K

C205

3.9K

R213

R209
56K

750

22u/50v
20K

10P/C
C206

IC201B

R206

R204
R215
22K

B20K
VR102C

10K

IC205A
JRC4558

R216
5.6K

1
320Hz

32Hz

6
5

SW100B
C208

X-OVER

823/M

R218

R212
15.2K

HIGH-2
B20K
VR102D

C207

X-OVER
1

10K

10K

101/C

2
R214

JRC4558

R211
750

JRC4558
IC104A

10K

56K

C203
102P

R122

R125
470K

R205
VR101B
C204

471/C

3
CH1+CH3
RCA OUT

R124
100K

IC201A
JRC4558
1 R203
1K

R202

7
JRC4558

C200

91K

C112

JRC4558

RCA1B
CH2 RCA IN

RCA1E
OUT

IC102B

R108
10K

C111

+6db

C110
393/MET

IC102A

R217

5.6K

320Hz

823/M

6
32Hz

IC205B
JRC4558

1K
2P3T

JRC4558
IC204B

R219

FULL-2

LOW-2

R207
10K

IC203B
JRC4558

R221
5.6K
B20K
VR103B

6.8K

BASS TO 45HZ

C211

+6db

C209
184/MET
C210
393/MET

RCA 4O
IC202A
1

IC202B

R208
10K

JRC4558

R223
24K

RCA1F
OUT

C212

5
7

6
JRC4558

10U

R224
100K

6
R220
1.8K

Odb

CH1

R121
B20K
VR103A

6.8K

6
R120
1.8K

R100

C100

RCA1A
CH1 RCA IN

471/C

R222
3.9K
JRC4558
IC204A

CH2+CH4
RCA OUT

R225
470K

IC105C

+15V

IC101C

IC102C

IC103C

IC104C

IC201C

IC202C

IC203C

IC204C

JRC4558

JRC4558

JRC4558

JRC4558

JRC4558

JRC4558

JRC4558

JRC4558
4

JRC4558

IC205C

TITLE:

JRC4558

DRAWN:

CZJ

-15V

DWG NO:

14

JBL CS5400-1
DATE:

CHECKED:

DATE:

APPROVED:

DATE:

2004-02-19
PT-I-B045-01-A1

REV:

2.0A

SHEET:

CH2

CS Series 50.4

91K

R301
47K
C301
22u/50v
C302

R304

1K

101/C
R302

R310

47K

56K

22u/50v

IC301A
JRC4558
1 R303

VR201A
C304
5

R309
56K

C303
102P

R315
22K

20K

JRC4558
IC301B
7

R305
R312
15.2K

10K

10K
C305

10K
R316
5.6K

1
320Hz

B20K
VR202B

C307

X-OVER
7

IC305B
JRC4558

HIGH-3
SW200A

B20K
VR202A

6
R314

10K

101/C

R306

22u/50v

R311
750

C306

X-OVER

823/M

R317

2
32Hz

C308

1
320Hz

5.6K

FULL-1

32Hz

1K
2P3T

JRC4558
IC304B

R319

IC305A
JRC4558

R318

823/M

LOW-1

R320
1.8K

R307
10K

IC303B
JRC4558

5.6K

10P/C

Odb

R313
750

BASS TO 45HZ

C309
184/MET

IC302A
RCA3O

10K

C400

91K

C402

3.9K

IC401A
JRC4558
1 R403

3
2

C405
10P/C

1K

101/C
R402

R410

47K

56K

R404

R405

R409
56K

C403
102P

JRC4558
IC304A

22u/50v

R322

R325
470K

JRC4558

R401
47K
C401
22u/50v

471/C

R308

VR201B
C404

20K

22u/50v

R415
22K

91K
R413
15K

C406

IC401B

R406

5
JRC4558

R411
750

B20K
VR202C

10K

6
R414

IC405B
JRC4558

10K

R416
5.6K

1
320Hz

32Hz

SW200B
C408

X-OVER

823/M

R417

R418

R412
15.2K

HIGH-4
B20K
VR202D

C407

X-OVER
7

10K

101/C

5.6K

1
320Hz

823/M

FULL-4

6
32Hz

IC405A
JRC4558

1K
2P3T

JRC4558
IC404B

R419

LOW-4

R407
10K

IC403B
JRC4558

R420
1.8K

5.6K
B20K
VR203B

6.8K

C411

+6db

C409
184/MET
C410
393/MET

IC302B
R408

10K

CH4

R421

BASS TO 45HZ

Odb

471/C

R422
3.9K
JRC4558
IC404A

3
RCA 4O

R425
470K

JRC4558

8
IC404C

JRC4558

JRC4558

JRC4558
4

JRC4558

IC403C

JRC4558

IC402C

JRC4558

8
IC401C

8
IC304C

JRC4558

IC303C

JRC4558

IC302C

JRC4558

8
IC301C

IC305C

+15V

R400

C311

+6db

C310
393/MET

CH3

R321
B20K
VR203A

6.8K

RCA1D
CH4 RCA IN

R300

C300

RCA1C
CH3 RCA IN

IC405C

TITLE:

JRC4558

DRAWN:

CZJ

-15V

DWG NO:

15

JBL CS5400-2
DATE:

CHECKED:

DATE:

APPROVED:

DATE:

2004-02-19
PT-I-B045-01-A1

REV:

2.0A

SHEET:

CS Series 50.4

C144
CH1
10U

CH1 R136
1K

R138 100

R142 100

100 R139

R143 100

Q144
945

4401

R154

Q139
A56

R151
R146
4.7K

47/C

C138
104/C

R149
0.2\5W

Q140
4401

Q143
4401

2.7K
C139
104M

R153
820
1

1.8K
R147
2.4K

R157
1k
C142
101/C

5.6K

R156
1k

+ C141
100U\16V

+ C140
100U/50V

PROTECT

Q142
2N6488

R144

Q137
4403

R140
18k

C137
101/c

Q138 C136

R141
18k

Q136
4403

MUTING

Q141
D1859

10k

Q135
4401

R135
10K

R155

+VCC
1N4002

R145
47

C135

R148
220

Q145
A06

0.2\5W
R150

4.7/0.5W

R137
1k

100U/50V

D135
+

Q147
2N6491

OUTL1

R152

C143
104/M

Q146
B1238

R158
47
D136

-VCC
1N4002

C244
CH2
10u

CH2 R236
1K

R238 100

R242 100

100 R239

R243 100

Q236
4403

MUTING

Q244
945

R240
18k

C237
101/c

Q238 C236

R241
18k

Q235
4401

10K
R235

R255

+VCC
1N4002

R245
47

C235

Q237
4403

4401

Q239
A56

47/C

R251

C238
104/C

R249
0.2\5W

Q240
4401

+ C240
100U/50V

C239
104M

R253
820
2

1.8K
R247
2.4K

R257
1k
C242

+ C241
100U\16V

PROTECT

Q243
4401

2.7K

R244

R248
220

Q245
A06

0.2\5W
R250

Q247
2N6491
Q246
B1238

R256
1k

10k
Q242
2N6488

R246
4.7K

101/C

5.6K

R254
Q241
D1859

4.7/0.5W

R237
1k

100U/50V

D235
+

OUTL2

R252

C243
104/M

R258
47
D236
-VCC
1N4002

TITLE:
DRAWN:

CZJ
DWG NO:

16

JBL CS5400-3
DATE:

CHECKED:

DATE:

APPROVED:

DATE:

2004-02-19
PT-I-B045-01-A1

REV:

2.0A

SHEET:

CS Series 50.4

R337
1k

C344
CH3
10U

CH3 R336
1K

100U/50V

D335
+VCC

C337
Q338 C336 101/c

R341
18k

Q335
4401
R338 100

R335
10K

R345
47

C335

4401

R342 100

R339 100
Q336
4403
Q344
945

10k

Q342
2N6488
R346
4.7K

R349
0.2\5W

Q340
4401

104/C

R351

C339
104M

R353
820
3

1.8K
Q337
4403

R347
2.4K

R357
1k
C342

R348
220

PROTECT

Q343
4401

2.7K

R344

R343 100
R340
18k

R354
Q341
D1859

Q339
A56

C338

47/C

1N4002

OUT3

0.2\5W
R350
R352
4.7/0.5W

R355

MUTING

101/C

5.6K

R356
1k

Q345
A06

+ C341
100U\16V

+ C340
100U/50V

Q346
B1238

Q347
2N6491

C343
104/M

R358
47
D336
-VCC
1N4002

R437
1k

C444
CH4
10U

CH4 R436
1K

100U/50V

D435

R435
10K

Q444
945

R445
47

C435

R442 100

R443 100
R440
18k

C437
101/c

Q438 C436

R441
18k

Q435
4401
R438 100

R439 100
Q436
4403

MUTING

+VCC

Q437
4403

4401

R454
Q441
D1859

Q439
A56

10k

R446
4.7K

104/C

R449
0.2\5W

Q440
4401

Q443
4401

2.7K
C439
104M

R453
820

R444

1.8K
R447
2.4K

R457
1k
C442

PROTECT

Q442
2N6488
R451

C438

47/C

1N4002

R448
220

OUTL4

0.2\5W
R450
R452
4.7/0.5W

R455
101/C

5.6

R456
1k

+ C440
100U/50V

+ C441
100U\16V

Q445
A06

Q446
B1238

Q447
2N6491

C443
104/M

R458
47
D436
-VCC
1N4002

TITLE:
DRAWN:

CZJ

DWG NO:

17

JBL CS5400-4
DATE:

2004-02-19

CHECKED:

PT-I-B045-01-A1

DATE:

REV:

APPROVED:

2.0A

DATE:
SHEET:

CS Series 50.4

J2
8P

REM
Q7
B1238

12

+12VB

R8
56K 1%

R47
10.5K1%
8

Q6
4403

PRO

D13
R21
0

C7
104/C

C6
104/C

10K1%

10.5K 1%

+ C5 4148
R23
200K 47U/25V

R19

R4

1
2
3

OUT3

220K
R5

3P

OUT2

220K

C9

C14
47U/16V

OUT1

220K

1
2
3
4
5
6
7
8

3
2
1

10/0.25W 104/C
PROTECT

22K
R52
36K

47U-LL

4148

R50
75K

D16*
4148

4148
R30

R48 C36

D15*

104/C

220K

J1

REM

OUT4

R6

Q3TL431

4
D12

C8

D9
5402

1000U/35 1000U/35

+12V Battery

3
F1B 25A
C17
1000u/35

R31

ZD1
5.6V

4148

Q2
4401

C16

R9
3k
D7

C15

R2

POWER-GND

U2A
LM358
2

F1A 25A
1

5MH

+12VB
R20 R51
10k 15K

R18
C3
3K
+
1U/50V

PROTECT

L1

R10
10K

D2 4148

R44
470K

C35

D3
4148

56K
C12

R13
104/C 1K

D1

Q1
K30

R12 100k

R52*

DCPROTECT
R34
47K

R1

4148

Q5
4401

-15V

100K

R7

MUTING

1K
C2
*22U/50v

Q4
4401

C1
NP22U/16V

C18
NP100U/16V

R3
100K

221/C

U1

TL494

1
2
3
4
5
6
7
8

U2B
LM358

D5
4148
16
15
14
13
12
11
10
9

R27
100

Q9
4403

R14
1K

RTH1 R24
10K 2.7K

R11
10K

C20
682/M

R36
2.2K

C21
22U/16V

100u/16V

RTH2
10k

T1

Q10
4403

R29
100
Q15
IRFZ46

12

C23 C25

ZD3
C27
15V 100U/16V

D10
2
2
16C20A

C11
104/C

R41
2.2K
C33

C31
104/C

R42
180K

R43
180K
C34

C28
100U/16V C30
R39
3K

C32
104/C
-vcc

R33

CON2

2.2U/16V

R45

Q17
4401

D11
4148

6.8K

-15V

Q8
B1238

47/0.5W

R40
1K

2.2U/16V
Q16
4401

ZD4
15V
C24 C26

4148

1
2

C29

3K

C10
104/C

R37
22

Q12
IRFZ46N

J3

+15V

R38

C22 3
681/C

4
R28
100

Q14
D1859

R32

47/0.5W

R15
1K

D6
ZD2
11V

R26
100

TL494

C19

R25
100

220U/25V

R35
18K

D14
4148

4148

2200/50V

C4
220U/16V

2200/50V

R22
2M

2200/50V

R17
12K

+VCC
1620
D8

2200/50V

R16
6.8K

R46
6.8K

Q13
IRFZ46N

220U/25V

Q11
IRFZ46N

D4

LED3
B LED

-VCC
C13

LED2
B LED

221/C

J4
1
2
CON2

LED1
B LED

TITLE:
DRAWN:

CZJ
DWG NO:

18

JBL CS5400-5
DATE:

CHECKED:

DATE:

APPROVED:

DATE:

2004-02-19
PT-I-B045-01-A1

REV:

2.0A

SHEET:

CS Series 50.4

19